TVR 280i, 350i parts catalogue
August 24, 2017 | Author: Jean Niemi | Category: N/A
Short Description
TVR 280i, 350i, parts catalogue...
Description
INTERPRETATION OF SPARE PARTS MANUAL
This manual is divided into sections as shown on the contents page . To locate a part refer to the contents page to establish the section and the appropriate text page reference number found in the top right hand corner of the list required . If the designation of the part is not known it may be identified by reference to the relevant illustration . The illustration item numbers are listed in numerical order in the tabulated list and part number description and number per car can be ordered by reading across the list. Usage will quickly make the reader familiar with the manual layout and no problem should be encountered location any part number.
HOW TO ORDER
In order to avoid delay the following information should be read carefully and the instructions followed closely to ensure that the factory, importer or dealer received sufficient information, in the approved form, to enable a speedy dispatch of the correct parts to be made. Orders for parts should be forwarded separately from correspondence dealing with other matters. The Chassis Number , Vehicle Identification Number and Engine Number, including all letter prefixed & suffixes of the car concerned must be quoted on every order . This information is given on the identification plate on the wheel arch of the vehicle and the engine cylinder block. The full part number and description of the parts required must always be given and if any doubt exists a sketch or pattern should be forwarded with the order. Specialist and other non standard equipment which is not listed in this Parts Catalogue may be ordered on a separate order form giving full details. Damaged and broken parts sent as patterns will not be returned unless specially requested .
Shown below is a typical example of the information required. FROM TVR MODEL ENGINE NUMBER CHASSIS or V .I .N .
. . . . . . . . . . . . . . ..
Item 1 Item 2 Item 3
025N 050A 025D 012b 025U 047A
Tachometer Rear road spring Door handle R .H .
1 off 2 off 1 off
DESPATCH TO ADDRESS METHOD OF TRANSPORT SIGNATURE DATE SPECIAL NOTE ;- As pipe and hose lengths may vary from time to time due to variations in production build, please state length required in addition to the part number in order that we may supply the correct item. Always specify the method of despatch required eg Airmail, Air Freight, Sea, Post, Passenger Train etc ., Confirmation orders must be clearly marked to avoid duplication. Crates and packing cases used for the despatch of goods will be charged for and credited in full if returned undamaged within one month.
PARTS CATALOGUE INDEX
El - ENGINE E2 - ENGINE E3 ENGINE E4 ENGINE E5 - ENGINE E6 - ENGINE E7 - ENGINE E8 - ENGINE E9 - ENGINE ElO - ENGINE E11 - ENGINE E12 - ENGINE E13 - ENGINE E14 - ENGINE E15 - ENGINE E16 - ENGINE E17 - ENGINE E18 - ENGINE E19 - ENGINE E20 - ENGINE E21 - ENGINE E22 - ENGINE E23 - ENGINE E24 - ENGINE E25 - ENGINE E26 - ENGINE E27 - ENGINE E28 - ENGINE E29 - ENGINE E30 - ENGINE E31 - ENGINE E32 - ENGINE E33 - ENGINE E34 - ENGINE E35 - ENGINE E36 - ENGINE
F1 GEARBOX F2 - GEARBOX F3 - GEARBOX F4 - GEARBOX F5 - GEARBOX F6 - GEARBOX F7 - GEARBOX F8 - GEARBOX F8A - GEARBOX F9 - GEARBOX F10 - GEARBOX F11 - GEARBOX F12 - GEARBOX F13 - GEARBOX F14 - GEARBOX
2801 FEDERAL AND EUROPEAN 2801 FEDERAL AND EUROPEAN 2801 PLENUM CHAMBER 2802 ANCILLERIES 2801 INTERNALS 2801 CAMSHAFT, CRANKSHAFT, PISTONS ETC 280I MOUNTING BRACKETS 350I EUROPEAN 350I CYLINDER BLACK 350/390/420 MOUNTING BRACKETS 350/390/420 PISTONS 350/390/420 CRANKSHAFT 350/390/420 SUMP 350/390/420 CAMSHAFT 350/390/420 FRONT COVER 350/390/420 WATER PUMP 350/390/420 DIAGNOSTIC TIMING 350/390/420 OIL PUMP 350/390/420 CYLINDER HEAD 350/390/420 ROCKER SHAFTS 350/390/420 ROCKER COVERS 350/390/420 INLET MANIFOLD 350/390/420 ACCELERATOR LINKAGE 350/390/420 RAM PIPE HOUSING 350/390/420 FUEL INJECTION 350/390/420 PLENUM CHAMBER 350/390/420 PLENUM HOSES 350/390/420 GASKET KITS 350/390/420 ALTERNATOR 350/390/420 ALTERNATOR MOUNTINGS 350 IGNITION COIL & DISTRIBUTOR 350/390/420 IGNITION COIL & DISTRIBUTOR 350/390/420 HIGH TENSION LEADS 350/390/420 STARTER MOTOR 350/390/420 FUEL INJECTION HARNESS, METER ETC 350/390/420 AIR FILTER ASSEMBLY
:
2801 FOUR SPEED 2801 FOUR SPEED INTERNALS 280I FIVE SPEED 2801 FIVE SPEED INTERNALS 2801 FIVE SPEED GEAR SHIFT COMPONENTS 280I THREE SPEED AUTOMATIC TRANSMISSION SELECTOR 280I THREE SPEED AUTOMATIC VEE 8 FIVE SPEED GEARBOX VEE 8 GEARCASE & CENTRAL PLATE VEE 8 EXTENSION CASE VEE 8 CONSTANT PINION/MAINSHAFT VEE 8 MAINSHAFT GEARS VEE 8 LAYSHAFT VEE 8 SELECTOR LINKAGE VEE 8 GEARCHANGE HOUSING
TVR ENGINEERING LIMITED PARTS CATALOGUE INDEX Al - CHASSIS ALL MODELS B1 - BODY 1980 SERIES I TASMIN 280I FIXEDHEAD B2 - BODY 1980 SERIES I TASMIN 280I CONVERTIBLE B3 - BODY SERIES I FEDERAL TASMIN 280I CONVERTIBLE B4 - BODY FEDERAL TASMIN 280I FIXEDHEAD B5 - BODY EUROPEAN TASMIN 2801 SERIES II FIXEDHEAD B6 - BODY EUROPEAN TVR 350I FIXEDHEAD B7 - BODY 1983 SERIES I TASMIN 350I CONVERTIBLE B8 - BODY 1985 SERIES II TVR 350I CONVERTIBLE B9 - BODY 1985 FEDERAL & EUROPEAN SERIES 1 TVR 280I CONVERTIBLE B10 - BODY 1986 FEDERAL & EUROPEAN SERIES II TVR 2801 CONVERTIBLE EUROPEAN TVR 2801 & 350I PLUS 2 FIXEDHEAD B11 - BODY B12 - BODY 1984 TVR 390 SE CONVERTIBLE B13 - BODY 1986 TVR 390 SE CONVERTIBLE 1986 TVR 420 SEAC CONVERTIBLE B14 - BODY B15 - REPAIR PANELS 280I CONVERTIBLE SERIESI B16 - REPAIR PANELS 200/280I CONVERTIBLE SERIES I B17 - REPAIR PANELS 350I CONVERTIBLE SERIES I B18 - REPAIR PANELS 280I CONVERTIBLE SERIES 1 B19 - REPAIR PANELS 280I SERIES II CONVERTIBLE B20 - REPAIR PANELS 350I/390 SERIES II CONVERTIBLE B21 - REPAIR PANELS 1986 390 SE CONVERTIBLE B22 - REPAIR PANELS 1986 420 SEAC B23 - REPAIR PANELS FEDERAL 280I SERIES 1 CONVERTIBLE B24 - REPAIR PANELS 280I SERIES I FIXEDHEAD - TWIN FILLERS B25 - REPAIR PANELS 280I SERIES II FIXEDHEAD & PLUS 2 B26 - REPAIR PANELS 350I FIXEDHEAD & PLUS 2 B27 - REPAIR PANELS FEDERAL 280I FIXEDHEAD
Cl - FRONT SUSPENSION ALL MODELS WITH REAR MOUNTED LEADING LINK C2 - FRONT SUSPENSION . . . . ALL MODELS WITH FORWARD MOUNTED LEADING LINK 390/420 MODIFIED ANTI ROLL BAR MOUNTING C3 - FRONT SUSPENSION
D1 - REAR SUSPENSION D2 - REAR SUSPENSION D3 - REAR SUSPENSION
1980/1983 280I MODELS ONLY 1983/1986 ALL MODELS 1986 ONWARDS WISHBONE SUSPENSION
PARTS CATALOGUE INDEX
GI G2 G3 G4 G5
- ROADWHEEL & TYRE - ROADWHEEL & TYRE - ROADWHEEL & TYRE - ROADWHEEL & TYRE - ROADWHEEL & TYRE
H1 H2 H3 H4 H5 H6 H7 H8 H9
-
STEERING STEERING STEERING STEERING STEERING STEERING STEERING STEERING STEERING
1980/1982 TELCAST 1982/1983 MOMO 1983 ON B .H .S. SPACESAVER SPARE 1986 420 SEAC MODEL
COLUMN & RACK 1980/1982 COLUMN & RACK 1982/1985 ADJUSTABLE COLUMN 1985 ON MANUAL RACK - CAM GEARS - BREAKDOWN POWER RACK - CAM GEARS - BREAKDOWN POWER RACK - TVR/SUPRA - BREAKDOWN PUMP - VEE6 WITH AIR CONDITIONING PUMP - VEE 8 RIGHT HAND DRIVE PUMP - VEE 8 LEFT HAND DRIVE
J1 J2 J3 J4 J5 J6 J7 J8 J9 J10 -
BRAKING BRAKING BRAKING BRAKING BRAKING BRAKING BRAKING BRAKING BRAKING BRAKING
SYSTEM SYSTEM SYSTEM SYSTEM SYSTEM SYSTEM SYSTEM SYSTEM SYSTEM SYSTEM
HANDBRAKE 1980 HANDBRAKE 1980 ONWARDS HYDRAULIC SYSTEM - GENERAL LAYOUT SERVO, MASTER CYLINDER & PIPES - R .H .D. SERVO, MASTER CYLINDER & PIPES - L .H .B. FRONT CALIPERS, DISCS & G VALVE REAR CALIPERS & DISCS PEDAL BOX - ALL MODELS WITH HYDRAULIC CLUTCH PEDAL BOX - AUTOMATIC TRANSMISSION SERVO & MASTER CYLINDER REPAIR KITS
K1 K2 K3 K4 K5 K6 K7
COOLING COOLING COOLING COOLING COOLING COOLING COOLING
SYSTEM SYSTEM SYSTEM SYSTEM SYSTEM SYSTEM SYSTEM
RADIATOR - SERIES I FIXEDHEAD 1980 280I RADIATOR & HOSES TO VIN 19442 - 1985 2801 RADIATOR & HOSES FROM VIN 19454 - 1985 RADIATOR & TWIN ELECTRIC FANS - CERTAIN MODELS RADIATOR & SINGLE ELECTRIC FAN - CERTAIN MODELS 3501 RADIATOR & HOSES - LEFT HAND DRIVE 350I RADIATOR & HOSES - RIGHT HAND DRIVE
-
LI L2 L3 -
FUEL SYSTEM FUEL SYSTEM FUEL SYSTEM
280I TANKS, HOSES & PUMP - SERIES I TO DH5256FI 280I TANKS, HOSES & PUMP - FEDERAL & EUROPEAN 350I EUROPEAN TANKS, HOSES & PUMP
PARTS CATALOGUE INDEX
Ml M2 M3 M4 M5 M6 M7 M8 M9 M10 M11 M12 M13 M14 M15 -
ELECTRICS RADIO CONSUL SWITCHES SERIES I TO DH5877FI ELECTRICS . . RADIO CONSUL SWITCHES - SERIES I FEDERAL TO VIN DH1216 ELECTRICS RADIO CONSUL SWITCHES ALL MODELS FROM NOVEMBER 1984 ELECTRICS . . RELAY/FUSE BOARD, HORNS & SWITCHES - SERIES I EUROPEAN ELECTRICS RELAY/FUSE BOARD - FEDERAL ELECTRICS FUSE BOARD - INSIDE CLOVEBOX - ALL MODELS ELECTRICS WINDOW REGULATOR, HORNS, SWITCHES ELECTRICS MIRRORS, LOUDSPEAKERS, ELECTRICAL AERIAL ELECTRICS WINDSHIELD WIPER, WASH ELECTRICS LIGHTS - FRONT, REAR & SIDE - FEDERAL & EUROPEAN ELECTRICS LIGHTS - REAR - EUROPEAN SERIES 1 MODELS ELECTRICS LIGHTS - REAR 350I SERIES II ELECTRICS LIGHTS - REAR 280I SERIES I & I ELECTRICS LIGHTS - FRONT - 420 SEAC ELECTRICS MIRRORS - FLAIRED TYPE - ALL MODELS
N1 - INSTRUMENTS N2 - INSTRUMENTS N3 - INSTRUMENTS
P1 P2 P3 P4 P5 P6
-
HEATING HEATING HEATING HEATING HEATING HEATING
Q1 Q2 Q3 Q4 Q5 Q6 Q7
-
CLUTCH CLUTCH CLUTCH CLUTCH CLUTCH CLUTCH CLUTCH
R1 R2 R3 R4 R5
-
& & & & & &
STEWART WARNER TYPE SMITHS TYPE VDO TYPE
VENTILATION VENTILATION VENTILATION VENTILATION VENTILATION VENTILATION
DIFFERENTIAL DIFFERENTIAL DIFFERENTIAL DIFFERENTIAL
& & & & DIFFERENTIAL &
280I SERIES I EUROPEAN - 2 VENT OUTLET ALL MODELS WITH A/C - 3 VENT OUTLET ALL CURRENT MODELS - 4 VENT OUTLET 2801 ENGINE BAY A/C - SERIES I FEDERAL 280I ENGINE BAY A/C - SERIES I/I FEDERAL 280I ENGINE PLENUM CHAMBER A/C SWITCH
280I EUROPEAN CABLE & EARLY HYDRAULIC 280I FEDERAL & EUROPEAN HYDRAULIC SYSTEM 280I HYDRAULIC SLAVE CYLINDER MASTER CYLINDER - ALL MODELS VEE 8 CLUTCH HOUSING VEE 8 FLYWHEEL & CLUTCH VEE 8 SLAVE CYLINDER
DRIVESHAFTS DRIVESHAFTS DRIVESHAFTS DRIVESHAFTS
TRAILING ARM TYPE CARRIER WISHBONE TYPE CARRIER DIFFERENTIAL ASSEMBLY . . DIFFERENTIAL BREAKDOWN - NON POWERLOK
DRIVESHAFTS
DIFFERENTIAL BREAKDOWN - POWERLOK
PARTS CATALOGUE INDEX
Si S2 S3 S4 S5 S6 S7 S8 S9 S10 -
T
U1 U2 U3 U4 U5
EXHAUST EXHAUST EXHAUST EXHAUST EXHAUST EXHAUST EXHAUST EXHAUST EXHAUST EXHAUST
280I SERIES I EUROPEAN - BELOW PROPSHAFT 280I SERIES I EUROPEAN - ABOVE PROPSHAFT 280I SERIES II EUROPEAN - TWIN SYSTEM UNDER FLOOR 2801 FEDERAL & CURRENT EUROPAN 3501 SERIES I - SINGLE SYSTEM 350/390 SERIES II - TWIN PIPE SYSTEM 3501 U .K . SPECIFICATION - TWIN PIPE OUTLET 350I EUROPEAN - TWIN PIPE OUTLET WITH REAR BOX 3502 PROPOSED SWISS SPECIFICATION 390/420 SINGLE OUTLET SYSTEM
- TOOLS & BOOKS
-
HARDTRIM HARDTRIM HARDTRIM HARDTRIM HARDTRIM
V1 - SOFT TRIM V2 - SOFT TRIM
FIXEDHEAD DOOR & BEAM - ALL EUROPEAN MODELS CONVERTIBLE DOOR & BEAM - FEDERAL GLASS - FIXEDHEAD RUBBER SEALS, IMPACT BEAMS ETC. SEALS & RUBBERS
CARPET - FIXEDHEAD CARPET - CONVERTIBLE
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION :
SECTION
Al
CHASSIS.
COMMENTS : ALL MODELS FROM 1980 DATE OF ISSUE - 1/5/86 ITEM 1
2
3
4
PART NO . 025A 081A
125A 111A
028A 121A
125A 131A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION
QUANTITY
280I - ALL MODELS UP TO DH5630FI VIN TV9RF28PXEBDH1052 - FRONT SUSPENSION WITH REAR MOUNTED LEADING LINK & ANTI - ROLL BAR.
1
280I - ALL MODELS FROM DH5631FI VIN TV9RF28P6EBDH1053 - FRONT SUSPENSION WITH FORWARD MOUNTED LEADING LINK & ANTI - ROLL BAR.
1
280I - R .H .D . ONLY WITH TVR/ROVER POWER STEERING RACK MOUNTS. FROM VIN
1
2801 - ALL MODELS - NEW REAR WISHBONE SUSPENSION . FROM VIN 1
5
020A 107A
200 - EUROPEAN ONLY.
6
035A 089A
350I - EUROPEAN - SINGLE EXHAUST. UP TO CH . NO . DH5862RI - SEPT . 1984
1
350I - EUROPEAN - TWIN EXHAUST. FROM CH . NO . DH587ORI - SEPT . 1984
1
350I - R .H .D . ONLY WITH TVR/ROVER POWER STEERING RACK MOUNTS. FROM VIN SA9DH35P5FBO19415 - JULY 1985
1
350/390 - EUROPEAN - ALL MODELS NEW REAR WISHBONE SUSPENSION FROM VIN SA9DH35P7GBO19109
1
350/390 - R .H .D . ONLY WITH TVR/ROVER POWER STEERING RACK MOUNTS AND NEW REAR WISHBONE SUSPENSION. FROM VIN SA9DH35P1GB019333
1
7
8
9
10
135A 113A
038A 122A
035A 129A
038A 130A
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
B1
DESCRIPTION : BODY - 1980 SERIES 1 TASMIN 280I FIXEDHEAD. COMMENTS :FROM 1980 CH . NO . DATE OF ISSUE - 1980 ITEM
PART NO .
9 10
0258 0258 025B 125E 125B 025B 0258 025B 025B 025B 025B 0258 025B 025B 025B
N/I N/I
025B 023A 025B 070A
1 2 3 4 5 6 7 8
054A 005A 006A 019A 003A 017A 038A 020A 021A 013A 014A 015A 016A 018A 055A
FHSO0I UNTIL CH . NO . FH5196FI
DATE REVISED
- 1980
DESCRIPTION BONNET COMPLETE HEADLIGHT POD - L .H . HEADLIGHT POD - R .H . BODYSHELL - R .H .D . BODYSHELL - L .H .D . BUMPER - FRONT SPOILER - FRONT DOOR - L .H . DOOR - R .H . SILL - L .H . SILL - R .H . B POST FINISHER - L .H . B POST FINISHER - R .H . BUMPER - REAR - FLUSH FITTING REAR EXHAUST VALANCE
DRAWING REFERENCE 241 QUANTITY 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
REAR BUMPER - WRAP AROUND EDGES 1 FRONT BUMPER - CIBIE SIDE/FLASHER ASS . 1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION B2
DESCRIPTION : 1980 SERIES 1 TASMIN 2801 CONVERTIBLE. COMMENTS :1980 FROM CH . NO . DHSO98FI - FEB . 1985 VIN TV9RF28P9FBDH1238 DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
PART NO . 025B 026V 025B 025B 026B 025E 026B 126B 025B 025B 026B 026B 025B 025B 026B 026V 026B 025B 026U 026U 026U 026B 026B
054A 212A 005A 006A 117A 038A 089A 090A 013A 014A 102A 103A 023A 030A 093A 296A 101A 071A 203A 202A 203A 172A 100A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION BONNET COMPLETE BONNET SOUNDPROOF MAT HEADLIGHT POD - L .H . HEADLIGHT POD - R .H . BUMPER - FRONT SPOILER - FRONT BODYSHELL - R .H .D . BODYSHELL - L .H .D . SILL - L .H . SILL - R .H . DOOR ASSEMBLY - L .H . DOOR ASSEMBLY - R .H . REAR BUMPER REAR EXHAUST VALANCE BOOT LID (WITHOUT FIRINGS) BOOT LID SOUNDPROOF MAT REAR HOOD MOULDING PETROL FILLER FLAP(WHERE FITTED) BOOT LID HINGE BOOT LID HINGE PAD - LARGE BOOT LID HINGE PAD - SMALL TARGA PANEL (COMPLETE/UNTRIMMED) HOOP
QUANTITY
.
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 2 2 1 1
201 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION : FEDERAL TASMIN 2801 CONVERTIBLE
SECTION B3 - SERIES1
COMMENTS : 1982 FROM VIN SH9TA13A2DBDH1001 TO VIN TV9RF28P7FBDH1238 -FEB 85 DATE OF ISSUE - 1/5/86 ITEM 1 2 3 3A 3B 4 5 6 7 8 9 10 11 12 12A 13 14 15 16 17
PART NO . 026B 026B 026U 026U 026U 026B 026V 125B 0258 026B 026B 126B 025B 025B 025B 125B 125V 025B 025B 026V 126B 025B 026B
172A 100A 201A 202A 203A 093A 296A 165A 030A 102A 103A 090A 013A 014A 038A 164A 411A 005A 006A 212A 167A 071A 101A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION TARGA PANEL (COMPLETE/UNTRIMMED) HOOP TRUNK LID HINGE TRUNK LID HINGE PAD - LARGE TRUNK LID HINGE PAD - SMALL TRUNK LID (WITHOUT FIXINGS) TRUNK LID SOUNDPROOF MAT REAR BUMPER ASSEMBLY (BLACK POLY .) REAR EXHAUST VALANCE DOOR ASSEMBLY - L .H . DOOR ASSEMBLY - R .H . BODYSHELL - L .H .D . LOWER ROCKER PANEL - L .H . LOWER ROCKER PANEL - R .H . SPOILER - FRONT FRONT BUMPER ASSEMBLY (BLACK POLY .) FRONT/REAR BUMPER RUBBER BEADING HEADLIGHT POD - L .H . HEADLIGHT POD - R .H . HOOD SOUNDPROOF MAT HOOD ASSEMBLY GAS FILLER FLAP REAR CONVERTIBLE TOP MOULDING
QUANTITY 1 1 2 2 2 1 1 1 1 1 1 1 1 1 1 1 A/R 1 1 1 1 1 1
20 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION B4
DESCRIPTION : FEDERAL TASMIN 280I FIXEDHEAD COMMENTS : SEPTEMBER 1983 FROM VIN TV9RF28PXEBFH1042 DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 11A 12 13 14 15
PART NO . 125E 125U 125U 025U 025U 030B 030B 125E 0258 030B 030B 0308 030B 030B 025E 125V 0258 025B 025V 030B 025B
190A 147A 148A 154A 120A 136A 137A 165A 030A 127A 128A 130A 131A 134A 164A 411A 005A 006A 234A 122A 071A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION BODYSHELL - L .H .D . TAILGATE HINGE - L .H . TAILGATE HINGE - R .H . TAILGATE HINGE RETAINER PLATE/BODY TAILGATE HINGE RETAINER PLATE/GLASS B POST FINISHER - L .H . B POST FINISHER - R .H . REAR BUMPER ASSEMBLY (BLACK POLY .) REAR EXHAUST VALANCE DOOR ASSEMBLY - L .H . DOOR ASSEMBLY - R .H . LOWER ROCKER PANEL - L .H . LOWER ROCKER PANEL - R .H . FRONT SPOILER FRONT BUMPER ASSEMBLY (BLACK POLY .) FRONT/REAR BUMPER RUBBER BEADING HEADLIGHR POD - L .H . HEADLIGHT POD - R .H . HOOD SOUNDPROOF MAT HOOD ASSEMBLY GAS FILLER FLAP
QUANTITY 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 A/R 1 1 1 1 1
24 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
B5
DESCRIPTION : EUROPEAN TASMIN 280I SERIES 11 FIXEDHEAD COMMENTS : 1981 FROM CHASSIS NUMBER DATE OF ISSUE - 1/5/86 ITEM 1 1 2 2 3 4 5 5 6 7 8 8 9 9 10 11 N/1 12 12 13 14 15
PART NO . 025B 125B 125U 125U 025U 025U 030B 030B 030B 0258 030B 030B 030B 030B 030B 030B 125V 0258 025B 025V 030B 025B
191A 190A 147A 148A 154A 120A 136A 137A 132A 030A 127A 128A 130A 131A 134A 129A 411A 005A 006A 234A 122A 071A
2FH5232FI
DATE REVISED
DRAWING REFERENCE 231
DESCRIPTION BODYSHELL - S11 - R .H .D . BODYSHELL - S11 - L .H .D . TAILGATE HINGE - L .H . TAILGATE HINGE - R .H . TAILGATE HINGE RETAINER PLATE/BODY TAILGATE HINGE RETAINER PLATE/GLASS B POST FINISHER - L .H . B POST FINISHER - R .H . REAR BUMPER REAR EXHAUST VALANCE DOOR ASSEMBLY - L .H . DOOR ASSEMBLY - R .H . SILL PANEL - L .H . SILL PANEL - L .H . FRONT SPOILER FRONT BUMPER FRONT/REAR BUMPER RUBBER BEADING HEADLIGHR POD - L .H . HEADLIGHT POD - R .H . HOOD SOUNDPROOF MAT HOOD ASSEMBLY GAS FILLER FLAP
QUANTITY 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 A/R 1 1 1 1 1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
B6
DESCRIPTION : EUROPEAN 350I FIXEDHEAD COMMENTS : 1983 FROM CHASSIS NUMBER - 2FH5571RI DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 N/I 11 12 13 14
PART NO .
DATE REVISED
DRAWING REFERENCE
DESCRIPTION
QUANTITY
035B 1358 125U 125U 025U 025U 030B 030B 035B
178A 177A 147A 148A 154A 120A 136A 137A 179A
BODYSHELL - R .H .D . BODYSHELL - L .H .D . TAILGATE HINGE - L .H . TAILGATE HINGE - R .H . TAILGATE HINGE RETAINER PLATE/BODY TAILGATE HINGE RETAINER PLATE/GLASS B POST FINISHER - L .H . B POST FINISHER - R .H . REAR BUMPER/EXHAUST VALANCE ASSEMBLY
1 1 1 1 1 1 1 1 1
030B 030B 030B 030B 035B 030B 125V 025B 025B 025V 035B 025B
127A 128A 130A 131A 180A 129A 411A 005A 006A 234A 152A 071A
DOOR ASSEMBLY - L .H . DOOR ASSEMBLY - R .H . SILL PANEL - L .H . SILL PANEL - R .H . FRONT SPOILER WITH RECESS FOR SPOTLIGHTS FRONT BUMPER FRONT/REAR BUMPER RUBBER BEADING HEADLIGHT POD - L .H . HEADLIGHT POD - R .H . BONNET SOUNDPROOF MAT BONNET ASSEMBLY FUEL FILLER FLAP
1 1 1 1 1 1 A/R 1 1 1 1 1
226 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION B7
DESCRIPTION : 1983 SERIES 1 TASMIN 3501 CONVERTIBLE. COMMENTS :1983 FROM CH . NO . DH5507RI TO JUNE 1985 CH . NO . DH6029RI DATE OF ISSUE - 1/5/86 ITEM 1 2 3 3 4 5 6 6 7 7 8 8 9 9A 10 11 12 13 14 15 16 17 18
PART NO . 036B 026V 025B 025B 026B 036B 036B 1368 036B 036B 026E 026B 0358 0358 0268 026V 026B 025B 026U 026U 026U 026E 0268
157A 212A 005A 006A 117A 153A 176A 175A 173A 174A 102A 103A 154A 154B 093A 296A 101A 071A 203A 202A 203A 172A 100A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
BONNET COMPLETE BONNET SOUNDPROOF MAT HEADLIGHT POD - L .H . HEADLIGHT POD - R .H . BUMPER - FRONT SPOILER - FRONT - WITH SPOTLIGHT RECESS BODYSHELL - R .H .D . SERIES 1 . BODYSHELL - L .H .D . SERIES 1 . SILL - L .H . - DIFFERENT FROM 2801 SILL - R .H . - DIFFERENT FROM 280I DOOR ASSEMBLY - L .H . DOOR ASSEMBLY - R .H . REAR BUMPER/VALANCE - SINGLE EXHAUST REAR BUMPER/VALANCE - TWIN EXHAUST BOOT LID (WITHOUT FIXINGS) BOOT LID SOUNDPROOF MAT REAR HOOD MOULDING PETROL FILLER FLAP BOOT LID HINGE BOOT LID HINGE PAD - LARGE BOOT LID HINGE PAD - SMALL TARGA PANEL (COMPLETE/UNTRIMMED) HOOP
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 2 2 1 1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION : 1985 SERIES 11
SECTION B8
350I CONVERTIBLE
COMMENTS :1985 FROM CHASSIS NUMBER - DH128ORI DATE OF ISSUE - 1/5/86 ITEM 1 2 3 3 4 5 5A 6 6 7 7 8 8 9 9 10 11 12 13 14 15 16 17 18 19
PART NO . 036B 026V 025B 025B 036B 0368 036B 0368 136B 036B 036E 0268 026B 036B 036B 0368 026V 026B 025B 026U 026U 026U 026E 026B 125V
194A 212A 005A 006A 195A 196A 197A 198A 199A 200A 201A 102A 103A 202A 203A 204A 296A 101A 071A 203A 202A 203A 172A 100A 411A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
BONNET COMPLETE BONNET SOUNDPROOF MAT HEADLIGHT POD - L .H . HEADLIGHT POD - R .H . BUMPER - FRONT SPOILER - FRONT - W/ARCH FLARE ON DAM SPOILER - FRONT - W/ARCH FLARE ON ARCH BODYSHELL - R .H .D . BODYSHELL - L .H .D . SILL - L .H . - DIFFERENT FROM Si SILL - R .H . - DIFFERENT FROM Si DOOR ASSEMBLY - L .H . DOOR ASSEMBLY - R .H . REAR BUMPER/EXHAUST VALANCE ASSEMBLY REAR BUMPER ASS . - SINGLE TWIN PIPE O/L BOOT LID (WITHOUT FIXINGS) BOOT LID SOUNDPROOF MAT REAR HOOD MOULDING PETROL FILLER FLAP BOOT LID HINGE BOOT LID HINGE PAD - LARGE BOOT LID HINGE PAD - SMALL TARGA PANEL (COMPLETE/UNTRIMMED) HOOP FRONT/REAR BUMPER RUBBER BEADING
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 2 2 1 1 A/R
182 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION : FEDERAL & EUROPEAN 280I SERIES 1
SECTION B9 1985 CONVERTIBLE - OCT .1986
COMMENTS : FROM VIN TV9RF28P9FBDH1239 TO VIN SA9DH28P3GBO19100 DATE OF ISSUE - 1/5/86 ITEM 1 2 3 3A 3B 4 5 6 7 8 8 9 9 10 10 11 12 12A 13 14 14 15 16 17 18 19
PART NO . 026B 026B 026U 026U 026U 036B 026V 125E 126U 026B 026B 126B 026B 025B 025B 126B 126E 125V 126U 025B 025B 026V 036E 0258 026E 126E
172A 100A 201A 202A 203A 204A 296A 183A 398A 102A 103A 205A 206A 013A 014A 184A 182A 411A 398A 005A 006A 212A 157A 071A 101A 185A
DATE REVISED DESCRIPTION
DRAWING REFERENCE 181 QUANTITY
TARGA PANEL (COMPLETE/UNTRIMMED) HOOP TRUNK LID HINGE _ TRUNK LID HINGE PAD - LARGE TRUNK LID HINGE PAD - SMALL TRUNK LID (ROUNDED SERIES 11 TYPE) TRUNK LID SOUNDPROOF MAT REAR BUMPER/EXHAUST VALANCE ASSEMBLY REAR BUMPER FOAM RUBBER INSERT(USA) DOOR ASSEMBLY - L .H . DOOR ASSEMBLY - R .H . BODYSHELL - L .H .D . - * NEW REAR LIGHTS* BODYSHELL - R .H .D . - *NEW REAR LIGHTS* LOWER ROCKER PANEL - L .H . LOWER ROCKER PANEL - R .H . SPOILER - FRONT - *CUT OUT FOR LIGHTS* FRONT BUMPER -*FOAM FILLED FIBERGLASS* FRONT/REAR BUMPER RUBBER BEADING FRONT BUMPER FOAM RUBBER INSERT(USA) HEADLIGHT POD - L .H . HEADLIGHT POD - R .H . HOOD SOUNDPROOF MAT HOOD ASSEMBLY GAS FILLER FLAP REAR CONVERTIBLE TOP MOULDING AIR CONDITIONING MATRIX COVER
1 1 2 2 2 1 1 1 1 1 1 1 1 1 1 1 1 A/R A/R 1 1 1 1 1 1 1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION B10
DESCRIPTION : FEDERAL & EUROPEAN 280I SERIES 11 1986 CONVERTIBLE. COMMENTS : FROM VIN
SA9DH28P1GB019001
DATE OF ISSUE - 1/5/86 ITEM 1 2 3 3A 3B 4 5 6 7 7A 7B 8 8 9 9 9 10 10 11 12 12A 12B 12C 13 13 14 15 16 17 18 19 18 19 20
PART NO . 026B 026B 026U 026U 026U 126B 026V 126B 126U 126U 126U 026B 026B 126B 026B 026B 026B 026B 026B 026B 125V 126U 126U 025E 025B 026V 036B 025B 026B 125U 125U 125U 125U 126B
172A 100A 201A 202A 203A 207A 296A 208A 399A 400A 401A 102A 103A 209A 210A 328A 211A 212A 213A 214A 411A 399A 402A 005A 006A 212A 157A 071A 101A 373A 374A 375A 376A 185A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
TARGA PANEL (COMPLETE/UNTRIMMED) HOOP TRUNK LID HINGE _ TRUNK LID HINGE PAD - LARGE TRUNK LID HINGE PAD - SMALL TRUNK LID WITH 86 STOP LIGHT APERTURE TRUNK LID SOUNDPROOF MAT REAR BUMPER/EXHAUST VALANCE ASSEMBLY REAR BUMPER SOLID RUBBER INSERT REAR BUMPER RUBBER INSERT PLUG - L .H . REAR BUMPER RUBBER INSERT PLUG - R .H . DOOR ASSEMBLY - L .H . DOOR ASSEMBLY - R .H . BODYSHELL - FEDERAL * FLARED BODY * BODYSHELL - R .H .D . - * FLARED BODY * BODYSHELL - L .H .D . EUROPEAN LOWER ROCKER PANEL - L .H .* FLARED * LOWER ROCKER PANEL - R .H .* FLARED * SPOILER - FRONT - *FLARED WITH LIGHTS* FRONT BUMPER -*FOAM FILLED ROUNDED* FRONT/REAR BUMPER RUBBER BEADING FRONT BUMPER SOLID RUBBER INSERT FRONT BUMPER RUBBER INSERT PLUG HEADLIGHT POD - L .H . HEADLIGHT POD - R .H . HOOD SOUNDPROOF MAT HOOD ASSEMBLY GAS FILLER FLAP REAR CONVERTIBLE TOP MOULDING MIRROR POD L .H . MIRROR HEAD L .H . MIRROR POD R .H . MIRROR HEAD R .H . AIR CONDITIONING MATRIX COVER
1 1 2 2 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 A/R 1 2 1 1 1 1 1 1 1 1 1 1 1
173 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
BI1
DESCRIPTION : EUROPEAN TASMIN 2801 & 350I PLUS 2 FIXEDHEAD COMMENTS : 2801 FROM CH . NO . FH5113FI2 1980 . 3501 FROM CH .NO . 2FH5546RI2 DATE OF ISSUE - 1/5/86 ITEM 1 1 1 1 2 2 3 4 5 5 6 7 7 8 8 9 9 10 10 11 11A 12 12 13 14 15
PART NO . 030B 030B 135B 035B 125U 125U 025U 025U 030B 030B 030B 025B 035B 030B 030B 030B 030B 030B 035B 030E 125V 025B 025B 025V 030E 025B
119A 118A 192A 193A 147A 148A 154A 120A 136A 137A 132A 030A 179A 127A 128A 130A 131A 134A 180A 129A 411A 005A 006A 234A 122A 071A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION BODYSHELL +2 - 280I - L .H .D . BODYSHELL +2 - 280I - L .H .D . BODYSHELL +2 - 350I - L .H .D . BODYSHELL +2 - 350I - R .H .D . TAILGATE HINGE - L .H . TAILGATE HINGE - R .H . TAILGATE HINGE RETAINER PLATE/BODY TAILGATE HINGE RETAINER PLATE/GLASS B POST FINISHER - L .H . B POST FINISHER - R .H . REAR BUMPER - 280I REAR EXHAUST VALANCE - 280I REAR BUMPER/EXHAUST VALANCE - 350I DOOR ASSEMBLY - L .H . DOOR ASSEMBLY - R .H . SILL PANEL - L .H . SILL PANEL - L .H . FRONT SPOILER - 280I FRONT SPOILER FOR SPOTLIGHTS - 350I FRONT BUMPER - ALL MODELS FRONT/REAR BUMPER RUBBER BEADING HEADLIGHR POD - L .H . HEADLIGHT POD - R .H . HOOD SOUNDPROOF MAT HOOD ASSEMBLY GAS FILLER FLAP
QUANTITY 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 A/R 1 1 1 1 1
232 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION B12
DESCRIPTION : 1984 390 S .E . CONVERTIBLE COMMENTS :FROM SEPTEMBER 1984 FROM CHASSIS NUMBER - 5882RI390 DATE OF ISSUE - 1/5/86 ITEM 1 2 3 3 4 5 6 7 8 9 10 10 11 11 12 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 26 27 27
PART NO . 036B 026V 025E 025B 036E 039B 039B 039U 039B 039U 036B 136B 036B 036B 026B 0268 039B 039B 039U 035B 026V 026B 025B 026U 026U 026U 026B 026B 125V 125U 125U 125U 125U
194A 212A 005A 006A 195A 215A 319A 413A 216A 412A 198A 199A 200A 201A 102A 103A 217A 218A 414A 204A 296A 101A 071A 203A 202A 203A 172A 100A 411A 373A 375A 374A 376A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
BONNET COMPLETE 1 BONNET SOUNDPROOF MAT 1 HEADLIGHT POD - L .H . 1 HEADLIGHT POD - R .H . 1 BUMPER - FRONT 1 SPOILER - FRONT 1 SPOILER - FRONT - LATER TYPE LIP ON BODY1 GRILL - FRONT SPOILER 1 SPOILER - LIP - REAR OF FRONT SPOILER 1 HOSE - BRAKE VENT A/R BODYSHELL - R .H .D . 1 BODYSHELL - L .H .D . 1 SILL - L .H . 1 SILL - R .H . 1 DOOR ASSEMBLY - L .H . 1 DOOR ASSEMBLY - R .H . 1 REAR BUMPER . 1 REAR UNDER BUMPER SPOILER - TWIN EXHAUST1 BRACKET - SPOILER MOUNTING 1 BOOT LID (WITHOUT FIXINGS) 1 BOOT LID SOUNDPROOF MAT 1 REAR HOOD MOULDING 1 PETROL FILLER FLAP 1 BOOT LID HINGE 2 BOOT LID HINGE PAD - LARGE 2 BOOT LID HINGE PAD - SMALL 2 TARGA PANEL (COMPLETE/UNTRIMMED) 1 HOOP 1 FRONT/REAR BUMPER RUBBER BEADING A/R MIRROR POD - L .H . 1 MIRROR POD - R .H . 1 MIRROR HEAD - L .H . 1 MIRROR HEAD - R .H . 1
200 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION B13
DESCRIPTION : 1986 390 S .E . CONVERTIBLE - WITH FLARED WHEEL ARCHES COMMENTS :FROM OCTOBER 1985 FROM VIN SA9DH35P7GBO19109 DATE OF ISSUE - 1/5/86 , ITEM 1 2 3 3 4 5 6 7 8 9 9 10 10 11 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 25 26 26
PART NO . 039B 026V 025B 025B 036B 039B 039B 039U 039U 039B 139B 039B 039B 026B 026B 039B 039B 039U 035B 026V 026B 025B 026U 026U 026U 026B 026B 125V 125U 125U 125U 125U
219A 212A 005A 006A 195A 215A 216A 412A 413A 220A 221A 222A 223A 102A 103A 217A 224A 414A 204A 296A 101A 071A 203A 202A 203A 172A 100A 411A 373A 375A 374A 376A
DATE REVISED DESCRIPTION
DRAWING REFERENCE 227 QUANTITY
BONNET COMPLETE BONNET SOUNDPROOF MAT HEADLIGHT POD - L .H . HEADLIGHT POD - R .H . BUMPER - FRONT SPOILER - FRONT SPOILER - REAR OF FRONT SPOILER HOSE - AIR DAM TO BRAKE VENTS GRILL - FRONT SPOILER BODYSHELL - R .H .D . - *FLARED* BODYSHELL - L .H .D . - *FLARED* SILL - L .H .- *FLARED* SILL - R .H .- *FLARED* DOOR ASSEMBLY - L .H . DOOR ASSEMBLY - R .H . REAR BUMPER . REAR UNDER BUMPER SPOILER - ONE EXHAUST BRACKET - SPOILER MOUNTING BOOT LID (WITHOUT FIXINGS) BOOT LID SOUNDPROOF MAT REAR HOOD MOULDING PETROL FILLER FLAP BOOT LID HINGE BOOT LID HINGE PAD - LARGE BOOT LID HINGE PAD - SMALL TARGA PANEL (COMPLETE/UNTRIMMED) HOOP FRONT/REAR BUMPER RUBBER BEADING MIRROR POD - L .H . MIRROR POD - R .H . MIRROR HEAD - L .H . MIRROR HEAD - R .H .
1 1 1 1 1 1 1 A/R 1 1 1 1 1 1 1 1 1 2 1 1 1 1 2 2 2 1 1 A/R 1 1 1 1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION B14
DESCRIPTION : 1986 420 S .E .A .C . CONVERTIBLE COMMENTS: DATE OF ISSUE - 1/5/86 ITEM 1 2 3 3 4 5 6 6 7 7 8 8 9 9 10 10 11 12 13 14 15 16 17 18 19 20
PART NO . 039B 026V 042B 042B 024U 024U 042B 042B 042B 042B 026B 026B 125U 125U 125U 125U 042B 026B 042E 035B 026V 026U 026U 026U 026B 026E
219A 212A 237A 238A 410A 411A 320A 321A 322A 323A 102A 103A 373A 375A 374A 376A 326A 101A 327A 204A 296A 203A 202A 203A 172A 100A
DATE REVISED
DRAWING REFERENCE 220
DESCRIPTION
QUANTITY
BONNET COMPLETE BONNET SOUNDPROOF MAT HEADLIGHT POD - L,.H . HEADLIGHT POD - R .H . POLYCARBONATE FRONT LIGHT COVER BLACK PLASTIC INTAKE GRILL BODYSHELL - R .H .D . BODYSHELL - L .H .D . SILL - L .H . SILL - R .H . DOOR ASSEMBLY - L .H . DOOR ASSEMBLY - R .H . MIRROR POD - L .H . MIRROR POD - R .H . MIRROR HEAD - L .H . MIRROR HEAD - R .H . REAR BUMPER ASSEMBLY REAR HOOD MOULDING REAR WING BOOT LID BOOT LID SOUNDPROOF MAT BOOT LID HINGE BOOT LID HINGE PAD - LARGE BOOT LID HINGE PAD - SMALL TARGA PANEL (COMPLETE/UNTRIMMED) HOOP
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 2 2 1 1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION B15
DESCRIPTION : REPAIR PANELS - CONVERTIBLE - 280I - SERIES 1 COMMENTS : TWIN FUEL FILLERS & FORD REAR LIGHTS 1980 TO CH NO DH5256F1 DATE OF ISSUE - 1/5/86 ITEM 1 2 3 3 4 4 5 6 7 8
DATE REVISED
PART NO . 026B 026B 026B 026B 026B 026B 026B 026B 026B 026B
239A 240A 241A 242A 243A 244A 245A 246A 247A 248A
DRAWING REFERENCE 228
DESCRIPTION R .H . L .H . R .H . R .H . L .H . L .H . R .H . L .H . R .H . L .H .
1ST . 1ST . 2ND . 2ND . 2ND . 2ND . 3RD . 3RD . 4TH . 4TH .
QUARTER QUARTER QUARTER,QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER -
ALL MODELS ALL MODELS R .H .D . ONLY L .H .D . EUROPEAN R .H .D . ONLY L .H .D . EUROPEAN ALL MODELS ALL MODELS ALL MODELS ALL MODELS
QUANTITY 1 1 1 1 1 1 1 1 1 1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
B16
DESCRIPTION : REPAIR PANELS - CONVERTIBLE - 2801 & 200 SERIES 1 COMMENTS : SINGLE FUEL FILLER & FORD REAR LIGHTS 1981 FROM CH NO DH5257/2L DATE OF ISSUE - 1/5/86 ITEM 1
2 3 3 4 4
5 6 7 8
DATE REVISED DESCRIPTION
PART NO . 026E 026E 026B 026B 026B 026B 026B 026B 026E 026B
239A 240A 241A 242A 243A 244A 249A 250A 247A 248A
DRAWING REFERENCE 228
R .H . L .H . R .H . R .H . L .H . L .H . R .H . L .H . R .H . L .H .
1ST . QUARTER - ALL MODELS 1ST . QUARTER - ALL MODELS
2ND . 2ND . 2ND . 2ND . 3RD . 3RD . 4TH . 4TH .
QUARTERQUARTER QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER -
R .H .D . ONLY L .H .D . EUROPEAN R .H .D . ONLY L .H .D . EUROPEAN ALL MODELS ALL MODELS ALL MODELS ALL MODELS
QUANTITY 1 1 1 1 1 1 1 1 1 1
REMARKS
SECTION
TVR ENGINEERING LIMITED PARTS CATALOGUE .
B17
DESCRIPTION : REPAIR PANELS - CONVERTIBLE - 3501 SERIES 1 COMMENTS : 1983 FROM CH . NO . DH5507RI TO JUNE 1985 CH . NO . DH6029RI. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 3 4 4 5 6 7 8
DESCRIPTION
PART NO . 026B 026B 026B 026B 0268 026B 026E 026B 026E 026B
239A 240A 251A 252A 253A 254A 249A 250A 247A 248A
DRAWING REFERENCE 228
DATE REVISED
R .H . L .H . R .H . R .H . L .H . L .H . R .H . L .H . R .H . L .H .
1ST. 1ST. 2ND. 2ND. 2ND. 2ND. 3RD. 3RD. 4TH. 4TH .
QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER
-
ALL MODELS ALL MODELS R .H .D . ONLY L .H .D . EUROPEAN R .H .D . ONLY L .H .D . EUROPEAN ALL MODELS ALL MODELS ALL MODELS ALL MODELS
QUANTITY 1 1 1 1 1 1 1 1 1 1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
B18
DESCRIPTION : REPAIR PANELS - CONVERTIBLE - 2801 SERIES 1 COMMENTS : WITH SD1 REAR LIGHTS - FEB 85 TO OCT 85 VIN 1239 TO VIN 9100 DATE OF ISSUE - 1/5/86 ITEM 1 2 3 3 4 4 5 6 7 8
DATE REVISED
PART NO . 026B 026B 026B 026B 026B 026E 026B 026E 026B 026B
239A 240A 241A 242A 243A 244A 249A 250A 255A 256A
DRAWING REFERENCE 228
DESCRIPTION R .H . L .H . R .H . R .H . L .H . L .H . R .H . L .H . R .H . L .H .
1ST . 1ST . 2ND . 2ND . 2ND . 2ND . 3RD . 3RD . 4TH . 4TH .
QUARTER QUARTER QUARTER,QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER -
ALL MODELS ALL MODELS R .H .D . ONLY L .H .D . EUROPEAN R .H .D . ONLY L .H .D . EUROPEAN ALL MODELS ALL MODELS ALL MODELS ALL MODELS
QUANTITY 1 1 1 1 1 1 1 1 1 1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
B19
DESCRIPTION : REPAIR PANELS - CONVERTIBLE - 280I SERIES 2 COMMENTS : FLAIRED BODY WITH SD1 REAR LIGHTS . FROM VIN 19001 OCT . 1985 ON.
DATE OF ISSUE - 1/5/86 ITEM 1
2 3 3 4 4
5 6 7 8 8 8
DATE REVISED
PART NO . 026B 026B 026B 026B 026B 026B 026B 026B 026B 126E 126B 026B
257A 258A 259A 260A 261A 262A 263A 264A 265A 266A 324A 325A
DRAWING REFERENCE 228
DESCRIPTION R .H . L .H . R .H . R .H . L .H . L .H . R .H . L .H . R .H . L .H . R .H . L .H .
1ST . QUARTER - ALL MODELS 1ST . QUARTER - ALL MODELS
2ND . 2ND . 2ND . 2ND . 3RD . 3RD . 4TH . 4TH . 4TH . 4TH .
QUARTER . QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER -
R .H .D . ONLY L .H .D . EUROPEAN R .H .D . ONLY L .H .D . EUROPEAN ALL MODELS ALL MODELS FEDERAL FEDERAL EUROPEAN * EUROPEAN *
QUANTITY
REMARKS
1 1 1 1 1 1 1 1 1 1 1 EUROPEAN 1 LICENCE
PLATE APERTURE
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
B20
DESCRIPTION : REPAIR PANELS - CONVERTIBLE - 350I/390 SE SERIES 2 COMMENTS : FLAIRED BODY WITH FEUGO REAR LIGHTS - FROM CH NO DH128ORI 1985 DATE OF ISSUE - 1/5/86 ITEM 1 1 2 2 3 3 4 4 5 6 7 8
DATE REVISED
PART NO . 036B 036B 036B 036B 036B 036B 036B 036B 036B 036B 036B 036B
267A 329A 268A 330A 269A 270A 271A 272A 273A 274A 275A 276A
DRAWING REFERENCE 228
DESCRIPTION R .H . R .H . L .H . L .H . R .H . R .H . L .H . L .H . R .H . L .H . R .H . L .H .
1ST . 1ST . 1ST . 1ST . 2ND . 2ND . 2ND . 2ND . 3RD . 3RD . 4TH . 4TH .
QUARTER QUARTER QUARTER , QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER -
EARLY MODELS * LATER MODELS * EARLY MODELS * LATER MODELS * R .H .D . ONLY L .H .D . EUROPEAN R .H .D . ONLY L .H .D . EUROPEAN ALL MODELS ALL MODELS ALL MODELS ALL MODELS
QUANTITY 1 1 1 1 1 1 1 1 1 1 1 1
REMARKS
SEE NOTE 1 BELOW
PLEASE NOTE* EARLY MODELS HAD A LIP ON THE FRONT SPOILER AND THEREFORE A DIFFERENT PROFILE ON THE SPOILER TO BODY LATER VEHICLES HAVE THE LIP ON THE BODY AND THEREFORE CARE SHOULD BE TAKEN IN ORDERING REPLACEMENT PANELS FOR THESE VEHICLES .
SECTION
TVR ENGINEERING LIMITED PARTS CATALOGUE .
B21
DESCRIPTION : REPAIR PANELS - CONVERTIBLE - 390 SE - 1986 COMMENTS : FLAIRED BODY WITH FEUGO REAR LIGHTS - FROM VIN SA9DH35P7GB019109 DATE OF ISSUE - 1/5/86 ITEM 1 2 3 3 4 4 5 6 7 8
DESCRIPTION
PART NO . 039B 039B 036E 036B 036B 036B 039B 039B 036B 036B
277A 278A 269A 270A 271A 272A 279A 280A 275A 276A
DRAWING REFERENCE 228
DATE REVISED
R .H . L .H . R .H . R .H . L .H . L .H . R .H . L .H . R .H . L .H .
1ST . 1ST . 2ND . 2ND . 2ND . 2ND . 3RD . 3RD . 4TH . 4TH .
QUARTER QUARTER QUARTER 'QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER -
ALL MODELS ALL MODELS R .H .D . ONLY L .H .D . EUROPEAN R .H .D . ONLY L .H .D . EUROPEAN ALL MODELS ALL MODELS ALL MODELS ALL MODELS
QUANTITY 1 1 1 1 1 1 1 1 1 1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
B22
DESCRIPTION : REPAIR PANELS - CONVERTIBLE - 420 SEAC 1986 COMMENTS: DATE OF ISSUE - 1/5/86 ITEM 1 2 3 3 4 4 5 6 7 8
DATE REVISED
PART NO . 042A 042A 042A 042A 042A 042A 042A 042A 042A 042A
281A 282A 283A 284A 285A 286A 287A 288A 289A 290A
DRAWING REFERENCE 228
DESCRIPTION R .H . L .H . R .H . R .H . L .H . L .H . R .H . L .H . R .H . L .H .
1ST . 1ST . 2ND . 2ND . 2ND . 2ND . 3RD . 3RD . 4TH . 4TH .
QUARTER QUARTER QUARTER 'QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER QUARTER -
ALL MODELS ALL MODELS R .H .D . ONLY L .H .D . EUROPEAN R .H .D . ONLY L .H .D . EUROPEAN ALL MODELS ALL MODELS ALL MODELS ALL MODELS
QUANTITY REMARKS 1 1 1 1 1 1 1 1 1 1
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
B23
DESCRIPTION : REPAIR PANELS - CONVERTIBLE - 280I FEDERAL SERIES 1 COMMENTS :1982 FROM VIN SH9TA13A2DBDH1001 TO VIN TV9RF28P7FBDH1238 - FEB 85 DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8
DATE REVISED
PART NO . 026B 026B 026B 026B 026B 026B 126B 126B
239A 240A 242A 244A 249A 250A 291A 292A
DESCRIPTION R .H . L .H . R .H . L .H . R .H . L .H . R .H . L .H .
1ST . 1ST . 2ND . 2ND . 3RD . 3RD . 4TH . 4TH .
QUARTER QUARTER QUARTER' QUARTER QUARTER QUARTER QUARTER QUARTER
DRAWING REFERENCE 228 QUANTITY 1 1 1 1 1 1 1 1
REMARKS
I TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
B24
DESCRIPTION : REPAIR PANELS - FIXEDHEAD - 280I SERIES 1 - TWIN FILLERS COMMENTS :1980 FROM CH . NO . FHSO01 TO CH . NO . FH5196FI 1981 DATE OF ISSUE - 1/5/86 ITEM 1 2 3 3 4 5
PART NO . 025B 025B 025B 025B 025B 025B
293A 294A 295A 296A 297A 298A
DATE REVISED DESCRIPTION
R .H . 1ST . QUARTER - ALL L .H . 1ST . QUARTER - ALL PASSENGER COMPARTMENT PASSENGER COMPARTMENT R .H . REAR QUARTER - ALL L .H . REAR QUARTER - ALL
DRAWING REFERENCE 225 QUANTITY MODELS 1 MODELS 1 R .H .D. 1 L .H .D . EUROPEAN 1 MODELS 1 MODELS 1
REMARKS
1 TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
B25
DESCRIPTION : REPAIR PANELS - FIXEDHEAD - 280I SERIES 2 & PLUS 2 MODELS COMMENTS :1981 FROM CH . NO . 2FH5232FI DATE OF ISSUE - 1/5/86 ITEM 1 2 3 3 3 3 3 3 4 4 4 5 5
DATE REVISED
PART NO . 0308 0308 030B 0308 0308 030B 030B 0308 030B 030B 030B 030B 030B
299A 300A 301A 302A 303A 304A 305A 306A 307A 308A 309A 310A 311A
DRAWING REFERENCE 225
DESCRIPTION R .H. 1ST . L .H. 1ST . PASSENGER PASSENGER PASSENGER PASSENGER PASSENGER PASSENGER R .H. REAR R .H. REAR R .H. REAR L .H. REAR L .H . REAR
QUARTER - ALL MODELS QUARTER - ALL MODELS COMPARTMENT - R .H .D. COMPARTMENT - L .H .D . COMPARTMENT - R .H .D. COMPARTMENT - L .H .D . COMPARTMENT - PLUS 2 COMPARTMENT - PLUS 2 QUARTER QUARTER - PLUS 2 QUARTER - PLUS 2 QUARTER QUARTER - PLUS 2
QUANTITY 1 1 1 EUROPEAN 1 1 EUROPEAN 1 R .H .D. 1 L .H .D. 1 1 1 1 1 1
REMARKS
TWIN FILLER TWIN FILLER ONE FILLER ONE FILLER
NO FILLER TWIN FILLER ONE FILLER NO FILLER TWIN FILLER
PLEASE NOTE ;- ON 280I MODELS CALLED SERIES 2 THE REFERENCE TO TWIN, SINGLE OR NO FILLER IS THE POSITION OF THE FUEL FILLER FLAP . ON EARLIER PLUS 2 MODELS THERE WERE TWIN FILLERS LOCATED IN BOTH REAR QUARTERS . AT THE SAME TIME ON NON PLUS 2 VEHICLES THERE WERE TWO FILLERS LOCATED IN THE PASSENGER COMPARTMENT. LATER PLUS 2 MODELS HAD A SINGLE FILLER IN THE REAR R .H . QUARTER WHILE THE LATER NON PLUS 2 MODELS HAD A SINGLE FILLER LOCATED ON THE R .H . SIDE OF THE PASSENGER COMPARTMENT .
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
B26
DESCRIPTION : REPAIR PANELS - FIXEDHEAD - 350I & PLUS 2 MODELS. COMMENTS :1983 FROM CH . NO . 2FH5571RI DATE OF ISSUE - 1/5/86 ITEM 1 2 3 3 3 3 4 4 4 5 5
DATE REVISED
PART NO . 035B 035B 030B 030B 030B 030B 030B 035B 030B 030B 035B
312A 313A 303A 304A 305A 306A 307A 314A 309A 310A 315A
DESCRIPTION R .H . 1ST . L .H . 1ST . PASSENGER PASSENGER PASSENGER PASSENGER R .H . REAR R .H . REAR R .H . REAR L .H . REAR L .H . REAR
DRAWING REFERENCE 225 QUANTITY
QUARTER - ALL MODELS 1 QUARTER - ALL MODELS 1 COMPARTMENT - R .H .D . 1 COMPARTMENT - L .H .D . EUROPEAN 1 COMPARTMENT - PLUS 2 R .H .D . 1 COMPARTMENT - PLUS 2 L .H .D . 1 QUARTER - EARLY MODELS SHORT BUMPER QUARTER - LATER MODELS LONG BUMPER QUARTER PLUS 2 - ONE FILLER QUARTER - EARLY MODELS SHORT BUMPER QUARTER - LATER MODELS LONG BUMPER
REMARKS
1 1 1 1 1
PLEASE NOTE ;- ON 350I MODELS THE REAR QUARTERS WERE MODIFIED IN LATER PRODUCTION WHEN THE REAR BUMPER WAS EXTENDED TO MEET THE REAR OF THE REAR WHEEL ARCH . WHEN ORDERING REPLACEMENT PANELS FOR THIS SECTION PLEASE ENSURE WHAT . TYPE OF BUMPER THE VEHICLE WAS FITTED WITH .
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
DESCRIPTION : REPAIR PANELS - FIXEDHEAD - 280I FEDERAL
B27
MODELS.
COMMENTS :FROM SEPTEMBER 1983 VIN TV9RF28PXEBFH1042 DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5
DATE REVISED DESCRIPTION
PART NO . 030B 030B 125B 125B 125B
299A 300A 316A 317A 318A
R .H . 1ST . L .H . 1ST . PASSENGER R .H . REAR L .H . REAR
DRAWING REFERENCE 225 QUANTITY
QUARTER QUARTER COMPARTMENT - L .H .D . FEDERAL QUARTER - FEDERAL QUARTER - FEDERAL
1 1 1 1 1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION : FRONT
SECTION
SUSPENSION - ALL MODELS WITH REAR MOUNTED LEADING LINK
COMMENTS :280I UP TO CH .NO . DH5630FI/ VIN TV9RF28PXEBDH1052 DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 6A 7 8 9 10 11 12 13 14 15 16 17 18 18 19 20 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 37 38 39 40 41 N/I N/I N/I
PART NO .
Cl
DATE REVISED DESCRIPTION
1983
DRAWING REFERENCE QUANTITY
FRONT DAMPER 025C 023A 025C OOIA UPPER WISHBONE NUT - UPPER WISHBONE 025C 038A WASHER - WISHBONE BOLT 025C 037A RUBBER BUSH - UPPER WISHBONE 025C 049A 025C 002A BOLT - UPPER WISHBONE DAMPER - TOP MOUNTING KIT 025C 082A DROP LINK 025C 028A 025C 018A WASHER - HEAVY - LEADING LINK ORANGE INSULATOR - LEADING LINK 025CO20A WASHER - LIGHT - LEADING ARM 025C 019A BLACK INSULATOR - LEADING ARM 025C 021A AS ITEM NO . 8. 025C 045A NUT - LEADING ARM CLAMP - ANTI-ROLL BAR MOUNTING 025C 017A 025C 016A RUBBER - ANTI ROLL-BAR MOUNTING 025C 026C ANTI - ROLL BAR 025C 044A NUT - LEADING ARM LEADING ARM - L .H . 025C 047A 025C 048A LEADING ARM - R .H . BOLT - LEADING ARM TO LOWER WISHBONE 025W 052A 025C 005A SPINDLE L .H . SPINDLE R .H . 025C 006A 025C 012A SEAL - WHEEL BEARING INNER 025C 008A BEARING - FRONT HUB INNER HUB ASSEMBLY 025C 007A 025C 027A STUD - FRONT WHEEL 025C O10A WASHER - HUB BEARING NUT - HUB BEARING 025C 011A 025C 013A RETAINER - HUB BEARING CAP - HUB BEARING 025C 015A 025C 014A SPLIT PIN BEARING - FRONT HUB OUTER 025C 009A 025C 004A BOLT - LOWER WISHBONE NUT - NYLOC - LEADING ARM TO WISHBONE 025W 018A LOWER WISHBONE 025C 003A NUT - LOWER WISHBONE 025C 039A BUSH - LOWER WISHBONE 025C 050A 025C 022A RUBBER PAD - FRONT SPRING ROAD SPRING - FRONT - CODE BLUE 125C 051A ROAD SPRING - FRONT - CODE GREEN 035C 062A 025C 042A NUT - UPPER & LOWER BALL JOINTS REPAIR KIT - BALL JOINT UPPER 025C 068A 025C 068B REPAIR KIT - BALL JOINT LOWER MOUNTING HUB - DROP LINK 025C 036A 025W 005A NUT - RETAINING DAMPER/IOWER WISHBONE LEADING ARM SPACER TUBE 025C 046A RUBBER BUSH - DROP LINK 025C 029A
2 2 2 8 4 2 2 2 2 2 4 2 2 2 2 1 4 1 1 4 1 1 2 2 2 10 2 2 2 2 6 2 2 4 2 2 2 2 2 2 4 2 2 2 4 2 2
233 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION : FRONT SUSPENSION - 280/350
SECTION
C2
- FORWARD MOUNTED LEADING LINK.
COMMENTS : 280I FROM DH5631FI/VIN TV9RF28P6EBDH1053 - 350I FROM DH5862RI. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 8A 9 10 11 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 31 32 33 34 35 36 37 38 39 39 40 41 42 43 44
PART NO . 025C 025C 025C 025C 025C 025C 025C 025C 025C 025W 025C 025C 025C 025C 025C 025J 025C 025J 025C 025C 025C 025C 025C 025C 025C 025C 025C 025W 025C 025C 025C 025C 125C 035C 035C 025C 025W 025W 035C 035C 035C 035C 035C 025C 025C 025C 025C 025C
023A 001A 038A 037A 049A 002A 082A 068A 068A 005A 041A 005A 006A 012A 008A OO1A 007A 002A 010A 011A 013A 015A 014A 009A 027A 042A 004A 018A 003A 050A 039A 022A 051A 062A 067A 029A 052A 032A, 060A 057A 059A 065A 066A 044A 018A 020A 019A 021A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
FRONT DAMPER UPPER WISHBONE NUT - UPPER WISHBONE WASHER - UPPER & LOWER WISHBONE BOLTS RUBBER BUSH - UPPER WISHBONE BOLT - UPPER WISHBONE DAMPER - TOP MOUNTING KIT REPAIR KIT - BALL JOINT UPPER REPAIR KIT - BALL JOINT LOWER RETAINING NUTS - FRONT DAMPER SPLIT PIN RETAINING BALL JOINTS SPINDLE - L .H . SPINDLE - R .H . SEAL - INNER - FRONT BEARINGS BEARING - FRONT HUB - INNER DISC FRONT BRAKE HUB ASSEMBLY BOLT - FRONT HUB TO BRAKE DISC WASHER - FRONT HUB BEARING NUT - FRONT HUB BEARING RETAINER - FRONT HUB BEARING CAP - FRONT HUB SPLIT PIN - FRONT HUB BEARING - FRONT HUB OUTER STUD - FRONT HUB TO WHEEL NUT - BALL JOINTS BOLT - LOWER WISHBONE NUT - LEADING LINK TO WISHBONE LOWER WISHBONE BUSH - LOWER WISHBONE NUT - LOWER WISHBONE PAD - FRONT SPRING ROAD SPRING - CODE BLUE V6 ROAD SPRING - CODE GREEN V8 WASHER - ANTI ROLL BAR/DROP LINK BUSH - ANTI ROLL BAR/DROP LINK BOLT - LEADING LINK TO WISHBONE NUT - NYLOC - DROP LINK RETAINER WASHER - ANTI ROLL BAR/DROP LINK RUBBER - ANTI ROLL BAR/LEADING LINK WASHER - ANTI ROLL BAR/DROP LINK LEADING LINK - L .H . LEADING LINK - R .H . NUT - LEADING LINK LOCKNUT WASHER - THICK - LEADING LINK ORANGE INSULATOR - LEADING LINK WASHER - THIN - LEADING LINK BLACK INSULATOR - LEADING LINK
2 2 2 8 4 2 2 2 2 4 4 1 1 2 2 2 2 10 2 2 2 2 2 2 10 4 2 4 2 2 2 2 2 2 2 2 4 2 2 2 2 1 1 4 4 2 4 2
1 REMARKS
DATE OF ISSUE - 1/5/86 ITEM 45 46 47 48 49 50 51 52 53
PART NO . 025C 035C 035C 025W 035C 025W 025W 035C 035C
045A 053A 054A 020A 055A 006A 005A 069A 058A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION NUT - LEADING LINK ANTI ROLL BAR MOUNTING RUBBER - ANRI ROLL BAR BOLT - ANTI ROLL BAR MOUNTING BRACKET - ANTI ROLL BAR MOUNTING WASHER - ANTI ROLL BAR MOUNTING NUT - ANTI ROLL BAR MOUNTING SPLIT PIN - ANTI ROLL BAR/DROP LINK DROP LINK
QUANTITY 2 1 2 2 2 4 2 2 2
8A PRICE
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
C3
DESCRIPTION : FRONT SUSPENSION - 390/420 - MODIFIED ANTI-ROLL BAR MOUNTING. COMMENTS : 390 SE AND 420 SE FROM 01-01-86. DATE OF ISSUE - 1 5/86 ITEM 1 2 3 4 5 6 7 8 8A 9 10 11 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 31 32 33 34 35 36 37 38 39 39 40 41 42 43 44
PART NO . 025C 023A 025C OOIA 025C 038A 025C 037A 025C 049A 025C 002A 025C 082A 025C 068A 025C 068A 025W 005A 025C 041A 025C 005A 025C 006A 025C 012A 025C 008A 025J OO1A 025C 007A 025J 002A 025C O10A 025C 011A 025C 013A 025C 015A 025C 014A 025C 009A 025C 027A 025C 042A 025C 004A 025W 018A 025C 003A 025C 050A 025C 039A 025C 022A 125C 051A 035C 062A 035C 067A 025C 029A 025W 052A 025W 032A MODIFICATION MODIFICATION 035C 059A 035C 065A 035C 066A 025C 044A 025C 018A 025C 020A 025C 019A 025C 021A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
FRONT DAMPER UPPER WISHBONE NUT - UPPER WISHBONE WASHER - UPPER & LOWER WISHBONE BOLTS RUBBER BUSH - UPPER WISHBONE BOLT - UPPER WISHBONE DAMPER - TOP MOUNTING KIT REPAIR KIT - BALL JOINT UPPER REPAIR KIT - BALL JOINT LOWER RETAINING NUTS - FRONT DAMPER SPLIT PIN RETAINING BALL JOINTS SPINDLE - L .H . SPINDLE - R .H . SEAL - INNER - FRONT BEARINGS BEARING - FRONT HUB - INNER DISC FRONT BRAKE HUB ASSEMBLY BOLT - FRONT HUB TO BRAKE DISC WASHER - FRONT HUB BEARING NUT - FRONT HUB BEARING RETAINER - FRONT HUB BEARING CAP - FRONT HUB SPLIT PIN - FRONT HUB BEARING - FRONT HUB OUTER STUD - FRONT HUB TO WHEEL NUT - BALL JOINTS BOLT - LOWER WISHBONE NUT - LEADING LINK TO WISHBONE LOWER WISHBONE BUSH - LOWER WISHBONE NUT - LOWER WISHBONE PAD - FRONT SPRING ROAD SPRING - CODE BLUE V6 ROAD SPRING - CODE GREEN V8 WASHER - ANTI ROLL BAR/DROP LINK BUSH - ANTI ROLL BAR/DROP LINK BOLT - LEADING LINK TO WISHBONE NUT - NYLOC - DROP LINK RETAINER TO SUSPENSION - PART NOT REQUIRED. TO SUSPENSION - PART NOT REQUIRED. WASHER - ANTI ROLL BAR/DROP LINK LEADING LINK - L .H . LEADING LINK - R .H . NUT - LEADING LINK LOCKNUT WASHER - THICK - LEADING LINK ORANGE INSULATOR - LEADING LINK WASHER - THIN - LEADING LINK BLACK INSULATOR - LEADING LINK
2 2 2 8 4 2 2 2 2 4 4 1 1 2 2 2 2 10 2 2 2 2 2 2 10 4 2 4 2 2 2 2 2 2 2 2 4 2
2 1 1 4 4 2 4 2
224 REMARKS
DATE OF ISSUE - 1/5/86 ITEM 45 46 47 48 49 50 51 52 53 54 55 56 57 58
PART NO . 025C 035C 035C 025W 035C 025W 025W 035C 039C 039C 039C 039C 039C 039C
045A 053A 054A 020A 055A 006A 005A 069A 070A 083A 074A 073A 072A 071A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION NUT - LEADING LINK ANTI ROLL BAR MOUNTING RUBBER - ANRI ROLL BAR BOLT - ANTI ROLL BAR MOUNTING BRACKET - ANTI ROLL BAR MOUNTING WASHER - ANTI ROLL BAR MOUNTING NUT - ANTI ROLL BAR MOUNTING SPLIT PIN - ANTI ROLL BAR/DROP LINK DROP LINK - MODIFIED FOR 390/420 LOCKNUT - 1OMM ROSE BEARING - ANTI-ROLL BAR SPACERS ROSE BEARING PIVOT YOKE SPECIAL WASHERS
QUANTITY 2 1 2 2 2 4 2 2 2 2 2 4 2 2
8C PRICE
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
D1
DESCRIPTION : REAR SUSPENSION - 1980-APRIL 1983 280I MODELS ONLY. COMMENTS : ALLOY HUB CARRIER & SEPARATE TRAILING ARM - 2801 TO CH .DH5470FI. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
PART NO . 025D 025D 025D 025W 025W 025D 025D 025W 025W 025W 025D 025D 025W 025W 025W 025C 025D 025D 025D
006A 020A 009A 018A 036A 013A O10A 019A 033A 034A 021A 007A O10A 006A 005A 037A 008B O11A 012B
DATE REVISED
244
DRAWING REFERENCE
DESCRIPTION TRAILING ARM HUB CARRIER - COMPLETE WITH BEARINGS PIVOT ROD NUT - PIVOT ROD RETAINER WASHER LOWER LINK ASSEMBLY BUSH - LOWER SUSPENSION LINK NUT - TRAILING ARM PIVOT ROD WASHER - TRAILING ARM ADJUSTMENT WASHER - TRAILING ARM ADJUSTMENT PIVOT ROD - TRAILING ARM MOUNTING - RUBBER - TRAILING ARM BOLT - MOUNTING RUBBER TO CHASSIS WASHER NUT WASHER - SPECIAL WASHER - TRAILING ARM - OVERLOAD REAR SHOCK ABSORBER ROAD SPRING REAR
QUANTITY
REMARKS
2 2 2 6 10 2 4 2 A/R A/R 2 2 4 8 4 2 2 2 2
A/R - AS REQUIRED PLEASE NOTE :- DUE TO MATERIAL STRENGTHENING THE SEPARATE TRAILING ARM AND CAST ALLOY HUB CARRIERS ARE NOT NOW AVAILABLE AND ARE REPLACED WITH A ONE PIECE FABRICATED UNIT . FOR SUSPENSION HANDLING REASONS IT IS NECESSARY TO CHANGE BOTH SIDES IF A REPLACEMENT ALLOY CASTING IS REQUIRED .
P
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
D2
DESCRIPTION : REAR SUSPENSION - 1983/86 - ALL MODELS TILL REVISED 390 SE. COMMENTS : FROM CHASSIS NUMBER DH5471FI TO VIN SA9DH35P2GB019332 DATE OF ISSUE -1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 16 17 18 19 19 20 21
PART NO . 025W 025W 025D 025W 025D 025D 025C 025W 025W 025W 025W 025D 025D 025W 025W 025D 026D 025D 025D 025D 025D 025W 025D
018A 034A 021A 033A 008A 007A 037A 019A O10A 006A 005A O10A 013A 082A 083A 012B 033A 011A 034A 022A 030A 036A 015A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION NUT - PIVOT BOLTS RETAINER WASHER - ALSO USED FOR ADJUSTMENT PIVOT ROD - TRAILING ARM WASHER - TRAILING ARM ADJUSTMENT TRAILING ARM - OVERLOAD MOUNTING RUBBER - TRAILING ARM WASHER - SPECIAL NUT - TRAILING ARM PIVOT ROD BOLT - MOUNTING RUBBER TO CHASSIS WASHER NUT BUSH - LOWER SUSPENSION LINK LOWER SUSPENSION LINK ASSEMBLY NUT - 3/8" UNF HALF NUT TOP MOUNT NUT 3/8" UNF TOP SHOCKER MOUNT ROAD SPRING - CODE RED ROAD SPRING - CODE SILVER REAR DAMPER CONE WASHER HUB CARRIER C/W TRAILING ARM - L .H . HUB CARRIER C/W TRAILING ARM - R .H . WASHER HUB PIVOT BOLT
A/R - AS REQUIRED .
QUANTITY 4 A/R 2 A/R 2 2 2 2 4 8 4 4 2 2 2 2 2 2 4 1 1 2 2
02 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
D3
DESCRIPTION : WISHBONE REAR SUSPENSION - 1986 REVISED LAYOUT - 390 & 350 COMMENTS : 390 FROM VIN SA9DH35P7GBO19109 350 FROM VIN SA9DH35P3GBO19334 DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 22 23 24 25 26 27 27
PART NO . 025D 025W 025D 025W 025D 025D 025D 025W 025D 025D 025D 025D 025D 025D 025D 025D 025D 025D 025D 025D 025D 025D 025D 025D 025D 025D 026D 025D 042D
067A 053A 056A 018A 078A 074A 014A 031A 068A 069A 075A 041A 039A 038A 040A 036A 070A 073A 053A 050A 071A 042A 043A 077A 050A 072A 012B 011A 077A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
BOLT - M12 X 110 - CHASSIS/DIFF .BKT . PLAIN WASHER - M12, LOWER DIFFERENTIAL CARRIER NUT - NYLOC - M12 BOLT - 3 1/2" X 1/2" UNC - CHASSIS/BKT PLAIN WASHER - 1/2" BUSH - CARRIER & WISHBONE NUT - NYLOC - 1/2" UNC BOLT - M12 X 80 - CHASSIS/BKT - REAR BOLT - 1/2" X 3 1/2" UNF W'BONE/BKT . NUT - NYLOC - 1/2" UNF WISHBONE ADJUSTMENT STUD WISHBONE ADJUSTER WISHBONE ADJUSTING OUTER BUSH WISHBONE ADJUSTING LOCKNUT - 1" UNF WISHBONE ASSEMBLY BOLT - 1/2 UNC X 5" - W'BONE/HUB/FRONT BOLT - 1/2" UNF X 2 1/2" LINK/HUB BUSH - REAR TRAILING LINK / HUB TRAILING LINK STUB BOLT - 1/2-UNC X 6 1/2" W'BONE/REAR HUB L .H . HUB CARRIER R .H . HUB CARRIER LOCKNUT - TRAILING LINK STUB TRAILING LINK STUB BOLT - 1/2" UNF X 3" LINK/CHASSIS ROAD SPRING - RED - ALL MODELS REAR DAMPER - 350I & 2801 BILSTEIN REAR DAMPER - 390 & 420 ONLY
1 8 1 4 2 16 10 6 2 4 8 2 2 2 2 2 2 2 2 2 2 1 1 2 2 2 2 2
222 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
DESCRIPTION : ENGINE - 280I - FEDERAL & EUROPEAN - FORD H .C . VEE 6 COMMENTS : ALL 2801 MODELS UP TO VIN SA9DH28POFBO19442 DATE OF ISSUE ITEM
1 2 3 4 4 4 5 5 6 6 7 8 8A 9 10 11 12 12 13 14 14A 15 15A 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 34 35
PART NO . 025E 025E 025E 027E 025E 025E 125E 025E 125E 027E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 125E 125E 025E 025E 125E 025E 025E 025E 125E 025E 025E 025E 125E 025W 025W 125U 025W 025W 025W 025W 125E 125E 125E 025H 125E 025E 025P
006A 007A 667A 142A 003A 008A 146A 002A 155A 167A 031A 665A 030A 666A 018A 027A 019A 026A 033A 028A 032A 081A 151A 034A 035A 150A 171A 173A 039A 075A 172A 037A 025A 026A 002A 003A 193A 004A 015A 003A 015A 054A 059A 058A 172A 065A 046A 061B
DATE REVISED DESCRIPTION
DRAWING
REFERENCE
QUANTITY
ENGINE & 4 SPEED GEARBOX ENGINE SHORT ENGINE ASSEMBLY ENGINE & AUTOMATIC TRANSMISSION CLIP - THROTTLE BALL JOINT BRACKET ASSEMBLY - THROTTLE CABLE RETAINER - THROTTLE CABLE THROTTLE CABLE - R .H .D . THROTTLE CABLE - L .H .D . THROTTLE CABLE - AUTO DISTRIBUTOR CAP - MOTORCRAFT DISTRIBUTOR CAP - BOSCH DISTRIBUTOR ASSEMBLY - MOTORCRAFT DISTRIBUTOR ASSEMBLY - BOSCH WIRE MESH - BREATHER TUBE ROCKER COVER ( VALVE COVER ) - L .H . ROCKER COVER ( VALVE COVER ) - R .H . DIPSTICK SPARKPLUG LEAD SET ROCKER ( VALVE ) COVER GASKETS SPARK PLUGS - EUROPEAN SPECIFICATION SPARK PLUGS - U .S .A . SPECIFICATION HEATSHIELD - INJECTION PIPES - U .S .A. STARTER MOTOR ASSEMBLY SOLENOID - STARTER MOTOR HEATSHIELD - WARM UP REGULATOR - U .S .A . HOSE - WATER - THERMOSTAT TO ENGINE HOUSING - THERMOSTAT REAR THERMOSTAT GASKET - THERMOSTAT HOUSING - FRONT HOUSING - THERMOSTAT - FRONT WATER PUMP FAN - COOLING VISCOUS COUPLING - FAN NUT - NYLOCK - OIL COOLER BRACKET RET . WASHER - SMALL - OIL COOLER BRACKET BRACKET - OIL COOLER WASHER - LARGE -OIL COOLER BRACKET BOLT - OIL COOLER BRACKET/BODYSHELL WASHER - SMALL - OIL COOLER/BRACKET BOLT - OIL COOLER TO BRACKET OIL COOLER PIPE - OIL COOLER TO SANDWICH PLATE PIPE - OIL COOLER TO SANDWICH PLATE WARM UP REGULATOR SWITCH - THERMO TIME - U .S .A . SWITCH - THERMO TIME - EUROPEAN BELT - AIR CONDITION COMPRESSOR 1350KK
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 6 6 1 1 1 1 1 1 1 1 1 1 1 8 4 2 4 4 4 4 1 1 1 1 1 1 1
R
DATE OF ISSUE ITEM
DATE REVISED
PART NO .
DESCRIPTION
DRAWING REFERENCE QUANTITY
36 37
025P 049A 125K 007A
COMPRESSOR - AIR CONDITION BELT - ALTERNATOR 1182MM
1 1
38 39 39 40 40 41 42 N/I N/I N/I N/I
025E 029P 025E 025N 025N 125E 025M 025E 025E 027E 025E
ALTERNATOR ALTERNATOR/COMPRESSOR MOUNTING BKT .USA ALTERNATOR TOP MOUNTING ASS . - NON A/C TRANSMITTER - TEMPERATURE GAUGE -SMITHS TRANSMITTER - TEMPERATURE GAUGE - VDO SWITCH - THERMAL E .C .U . - U .S .A . AUXILIARY AIR DEVECE OIL FILTER AIR FILTER ELEMENT - PAPER BRACKET ASS . - THROTTLE CABLE - AUTO ENGINE & 5 SPEED GEARBOX
1 1 1 1 1 1 1 1 1 1 1
036A 062A 02OA 035A 089A 082A 173A 038A 045A 168A 052A
N/I - NOT ILLUSTRATED
18 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION E2
DESCRIPTION : ENGINE - 280I - FEDERAL & EUROPEAN - FORD H .C . VEE 6 UNIT COMMENTS :
ALL 280I MODELS FROM VIN SA9DH28P7FB01945442
DATE OF ISSUE - 1/5/86 ITEM
1 2 3 4 4 4 5 5 6 6 7 8 8A 9 10 11 12 12 13 14 14A 15 15A 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 30 31 32 33 34
PART N0 . 025E 025E 025E 027E 025E 025E 125E 025E 125E 027E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 125E 125E 025E 025E 125E 025E 025E 025E 125E 025E 025E 125E 125E 026E 025E 025E 025E 026E 125E 025M 125E 025E 028H 029P 125K
006A 007A 667A 142A 003A 008A 146A 002A 155A 167A 031A 665A 030A 666A 018A 027A 019A 029A 033A 028A 032A 081A 151A 034A 035A 150A 171A 173A 039A 075A 172A 037A 059A 054A 653A 668A 669A 670A 654A 058A 172A 065A 046A 090A 130A 007A
025E 036A
DATE REVISED DESCRIPTION
DRAWING REFERENCE
QUANTITY REMARKS
ENGINE & 4 SPEED GEARBOX 1 ENGINE 1 SHORT ENGINE ASSEMBLY 1 ENGINE & AUTOMATIC TRANSMISSION 1 CLIP - THROTTLE BALL JOINT 1 BRACKET ASSEMBLY - THROTTLE CABLE 1 RETAINER - THROTTLE CABLE 1 THROTTLE CABLE - R .H .D . 1 THROTTLE CABLE - L .H .D . 1 THROTTLE CABLE - AUTO 1 DISTRIBUTOR CAP - MOTORCRAFT 1 DISTRIBUTOR CAP - BOSCH 1 DISTRIBUTOR ASSEMBLY - MOTORCRAFT 1 DISTRIBUTOR ASSEMBLY - BOSCH 1 WIRE MESH - BREATHER TUBE 1 ROCKER COVER ( VALVE COVER ) - L .H . 1 1 ROCKER COVER ( VALVE COVER ) - R .H . DIPSTICK 1 1 SPARKPLUG LEAD SET ROCKER ( VALVE ) COVER GASKETS 2 SPARK PLUGS - EUROPEAN SPECIFICATION 6 SPARK PLUGS - U .S .A . SPECIFICATION 6 HEATSHIELD - INJECTION PIPES - U .S .A. 1 STARTER MOTOR ASSEMBLY SOLENOID - STARTER MOTOR 1 HEATSHIELD - WARM UP REGULATOR - U .S .A . 1 1 HOSE - WATER - THERMOSTAT TO ENGINE HOUSING - THERMOSTAT REAR 1 1 THERMOSTAT GASKET - THERMOSTAT HOUSING - FRONT 1 1 HOUSING - THERMOSTAT - FRONT WATER PUMP 1 PIPE - OIL COOLER/SANDWICH PLATE 4'51/2"1 OIL COOLER 1 1 MOUNTING BRACKET - OIL COOLER - L .H . 8 BOLT - BKT . TO BODY/BKT TO COOLER WASHER 8 NUT - NYLOC 8 1 MOUNTING BRACKET - OIL COOLER - R .H . PIPE - OIL COOLER/SANDWICH PLATE 3'81/2"1 WARM UP REGULATOR 1 1 SWITCH - THERMO TIME - U .S .A . 1 SWITCH - THERMO TIME - EUROPEAN BELT - AIR CONDITION COMPRESSOR 1325MM 1 1 COMPRESSOR - AIR CONDITION TYPE 508 1 BELT - ALTERNATOR ALTERNATOR
229
1
DATE OF ISSUE - 1/5/86 ITEM I PART NO . 35 35 36 36 37 38 N/I N/I N/I N/I
DATE REVISED DESCRIPTION
I DRAWING REFERENCE I
QUANTITY
ALTERNATOR/COMPRESSOR MOUNTING BKT .USA 029P 187A ALTERNATOR TOP MOUNTING ASS . NON A/C 025EO20A TRANSMITTER - TEMPERATURE GAUGE -SMITHS 025N 035A TRANSMITTER - TEMPERATURE GAUGE - VDO 025N 089A 125E 082A SWITCH - THERMAL E .C .U . - U .S .A . AUXILIARY AIR DEVICE 025H 173A 025E 038A OIL FILTER AIR FILTER ELEMENT - PAPER 025E 045A BRACKET ASS . - THROTTLE CABLE - AUTO 027E 168A ENGINE & 5 SPEED GEARBOX 025E 052A N/I - NOT ILLUSTRATED
1 1 1 1 1 1 1 1 1 1
229 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION :
SECTION
E3
280I PLENUM CHAMBER, INLET MANIFOLD & FUEL INJECTION
COMMENTS : FEDERAL AND EUROPEAN - ALL MODELS DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34
PART N0 . 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 125E 025M 025E 025E 025E 025E 025M 025E 025E 025E 025E 025E 025E 025E 025E 025E
671A 672A 673A 674A 675A 676A 677A 678A 679A 680A 681A 682A 683A 684A 685A 686A 687A 688A 150A 172A 689A 690A 691A 692A 173A 693A 694A 695A 696A 697A 698A 699A 700A 701A
DATE REVISED DESCRIPTION
DRAWING REFERENCE
T
QUANTITY
UNION - VACUUM TAKE OFF 1 COVER - UNION A/R PLENUM CHAMBER HOUSING 1 STUD - THROTTLE BODY TO PLENUM 4 WASHER - THROTTLE BODY TO PLENIM 4 NUT - RETAINER - THROTTLE BODY/PLENUM 4 BRACKET - THROTTLE CABLE RETAINER 1 WASHER - THROTTLE LEVER TO HOUSING 2 SPRING - RETURN - LEVER TO THROTTLE BKT .1 LEVER - THROTTLE 1 HOUSING - THROTTLE 1 MANIFOLD - INLET 1 SPRING - IDLE SPEED SCREW 1 SCREW - IDLE ADJUSTMENT 1 GASKET - THROTTLE BODY TO PLENUM 1 GASKET - PLENUM TO INLET MANIFOLD 1 PLATE - MOUNTING 1 NUT - SPACER FOR HEATSHIELD - USA 2 HEATSHIELD - WARM UP REGULATOR - USA 1 WARM UP REGULATOR 1 SCREW - REGULATOR TO MOUNTING PLATE 2 MOUNTING BLOCK - A .A .D . TO ENGINE 1 BOLT - A .A .D . TO MOUNTING BLOCK 2 WASHER - A .A .D . TO MOUNTING BLOCK 2 AUXILIARY AIR DEVICE ( A .A .D . ) 1 UNION - WATER INLET TO BLOCK 1 BOLT - COLD START VALVE TO PLENUM 2 WASHER - COLD START VALVE TO PLENUM 2 COLD START VALVE 1 GASKET - VALVE TO BODY 1 UNION - AIR INLET TO BLOCK 1 MOUNTING BLOCK - COLD START VALVE 1 GASKET - MOUNTING BLOCK TO PLENUM 1 UNION - CRANKCASE BREATHER TAKE OFF 1
87 REMARKS
I
E
C
N/I N/I N/I N/I
027E 027E 027E 027E
169A 168A 167A 170A
CLEVIS PIN - THROTTLE CABLE - MANUAL BRACKET ASS . - THROTTLE CABLE - AUTO THROTTLE CABLE - AUTOMATIC CLEVIS PIN - THROTTLE CABLE - AUTO
1 1 1 1
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
E4
DRAWING REFERENCE
22
DESCRIPTION : ENGINE - 280I ANCILLERIES COMMENTS :
FEDERAL & EUROPEAN - ALL MODELS
DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10
PART NO . 125E 025E 025E 125E 125E 125E 125W 125E 025U 125E
059A 163A 038A 056A 057A 055A 081A 058A 338A 063A
DATE REVISED DESCRIPTION
OIL COOLER PIPE - U .S .A . IGNITION ELECTRONIC CONTROL UNIT OIL FILTER SEALING RING - U .S .A . SANDWICH PLATE - U .S .A . EXTENSION BOLT - U .S .A . CLIPS - OIL COOLER PIPES - U .S .A . OIL COOLER PIPE - U .S .A . THROTTLE PEDAL SWITCH - WIDE OPEN THROTTLE - U .S .A .
QUANTITY 1 1 1 1 1 1 4 1 1 1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
E5
DRAWING REFERENCE
86
DESCRIPTION : 280I ENGINE - INTERNALS COMMENTS : FORD EUROPEAN 2 .8 LITRE H .C . VEE 6 UNIT DATE OF ISSUE - 1/5/86 ITEM
PART N0 .
DATE REVISED DESCRIPTION
QUANTITY
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 28A 29 30 31 32
025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 125E 125E 125E 025E 025E 025E 025E 025E 025E
027A 682A 109A 702A 028A 164A 044A 705A 706A 041A 040A 042A 043A 075A 712A 037A 713A 714A 715A 076A 717A 718A 719A 720A 056A 057A 055A 721A 722A 723A 724A 725A 726A
ROCKER COVER ( VALVE COVER ) - L .H . INLET MANIFOLD ROCKER COVER ( VALVE COVER ) - R .H . SCREWS - ROCKER COVERS ROCKER ( VALVE ) COVER GASKETS CYLINDER HEAD ASSEMBLY CYLINDER HEAD GASKET OIL SEAL - REAR - CRANKSHAFT CYLINDER BLOCK GASKET - SUMP SEAL KIT CRANKCASE SUMP DRAIN PLUG - SUMP WASHER - SEALING - SUMP PLUG GASKET - THERMOSTAT HOUSING - FRONT SPACER - THERMOSTAT HOUSING WATER PUMP ASSEMBLY GASKET - WATER PUMP OIL SEAL - CRANKSHAFT - FRONT COVER ASSEMBLY - TIMING CHAIN . GASKET - THERMOSTAT REAR HOUSING SEALING RING - GUIDE SLEEVE GASKET - FRONT COVER/INTERMEDIATE PLATE INTERMEDIATE PLATE GASKET - INTERMEDIATE PLATE/BLOCK SEALING RING - OIL SANDWICH PLATE SANDWICH PLATE - OIL FILTER EXTENSION BOLT - OIL FILTER VALVE - INLET VALVE - EXHAUST GUIDE - VALVE SPRING - VALVE CAP - VALVE SPRING SPLIT COTTERS
1 1 1 12 2 2 2 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 6 6 12 12 12 24
N/I N/I N/I N/I
025E 025E 025E 025E
645A 646A 647A, 648A
OIL PUMP QUILL SHAFT - OIL PUMP GASKET - OIL PUMP GASKET - OIL STRAINER
1 1 1 1
N/I
025E 651A
OVERHAUL GASKET KIT
1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION :
SECTION
E6
ENGINE - 280I - CAMSHAFT, CRANKSHAFT, PISTON ETC;
COMMENTS : FEDERAL & EUROPEAN - ALL MODELS DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 34A 35 36 37
PART NO . 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E 025E
727A 728A 729A 730A 731A 732A 733A 734A 735A 736A 705A 737A 738A 739A 740A 650A 741A 742A 743A 744A 745A 745A 746A 747A 649A 748A 749A 750A 751A 752A 753A 754A 755A 756A 757A 758A 759A 760A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
BOLT - ROCKER SHAFT ASS TO HEAD WASHER SHAFT - ROCKER PEDESTAL- ROCKER SHAFT TO HEAD SPRING - ROCKER SHAFT OIL THROWER - ROCKER SHAFT BEARINGS - CAMSHAFT CAMSHAFT PISTON RING - SET PILOT BEARING CRANKSHAFT OIL SEAL - REAR - CRANKSHAFT CRANKSHAFT MAIN BEARINGS - SET MAIN BEARING CAP BOLT - MAIN BEARING CAP GEAR - CRANKSHAFT PULLEY - CRANKSHAFT CONNECTING ROD & CAP ASSEMBLY BEARING SET - CONNECTING ROD (BIG END) BOLT - CONNECTING ROD NUT - CONNECTING ROD PISTON ASSEMBLY OIL SEAL - CAMSHAFT THRUST PLATE - CAMSHAFT GEAR - CAMSHAFT BOLT - GEAR RETAINER WASHER - GEAR RETAINER BOLT - THRUST PLATE RETAINER WASHER - THRUST PLATE RETAINER TAPPET PUSH ROD SPLIT PIN - ROCKER SHAFT RETAINER SPRING - SHAFT END ROCKER - R .H . ROCKER - L .H . BOLT - TAPPET ADJUSTMENT SPACER - ROCKER PEDESTAL PLUG - SHAFT ENDS
6 6 2 6 4 2 4 1 6 1 1 1 8 4 8 1 1 6 12 12 12 6 1 1 1 1 1 2 2 6 6 2 2 6 6 12 6 4
88 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
E7
DESCRIPTION : ENGINE - 280I - MOUNTING BRACKETS & INSULATORS COMMENTS : SPECIAL TVR UNITS. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 11A 12 13 14 15 16 17 18 19 20 21
PART NO .
125E 025E 025E 025E 025E 025E 025W 025E 025W 025W 025F 025E 025E 025W 025E 025E 025E 025E 025E 025E 020E 025E
148A 023A 001A 761A 762A 763A 101A 763A 009A 006A 002A 766A 765A 005A 763A 762A 768A 769A 762A 763A 129A 770A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION MOUNTING PLATE - L .H . MOUNTING PLATE - R :H . INSULATOR - R .H . BOLT - MOUNTING PLATE M10 X 35 WASHER - SPRING WASHER - PLAIN - LARGE BOLT - GEARBOX MOUNTING 12 X 25MM WASHER - PLAIN BOLT - CHASSIS TO INSULATOR M8 X 35 WASHER - PLAIN - M6 INSULATOR - GEARBOX/CHASSIS WASHER - 8MM WASHER - PIAIN - SMALL NUT - NYLOC - M8 WASHER - PLAIN - LARGE WASHER - SPRING BOLT - MOUNTING PLATE - M10 X 25 NUT - PLAIN INSULATOR MOUNTING WASHER - SPRING WASHER - PLAIN - LARGE INSULATOR - L .H . NUT - NYLOC
QUANTITY 1 1 1 3 3 3 1 1 2 2 1 2 2 2 3 3 3 2 4 4 1 2
146 REMARKS
SECTION
TVR ENGINEERING LIMITED PARTS CATALOGUE .
E8
DESCRIPTION : ENGINE - 350I - EUROPEAN COMMENTS : ROVER VITESSE 3 .5 LITRE INJECTED VEE 8 UNIT DATE OF ISSUE - 1/5/86 ITEM
1 2 3
PART NO .
035E 083A 035E 158A 035E 177A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION
ENGINE & 5 SPEED GEARBOX ASSEMBLY ENGINE & AUTOMATIC GEARBOX ASSEMBLY SHORT ENGINE ASSEMBLY
QUANTITY
1 1 1
117 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION : COMMENTS :
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 N/I N/I N/I
ROVER VITESSE 3 .5 LITRE INJECTED VEE 8 UNIT DATE REVISED
PART NO . 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E
E9
ENGINE - 350I - CYLINDER BLACK
DATE OF ISSUE - 1/5/86 ITEM
SECTION
178A 179A 180A 181A 182A 183A 184A 185A 186A 187A 188A 189A 190A 191A 192A 193A 194A 195A 196A 197A 198A
DRAWING REFERENCE
DESCRIPTION STUD - TIMING POINTER CUP - PLUG PLUG, TAPPET/ANGULAR HOLES PLUG, TAPPET LINE, REAR PLUG, CAM BORE, REAR BOLT, 1/2- UNC, MAIN BEARING CAP DOWEL, FLYWHEEL HOUSING DRAIN TAP PLUG - ALTERNATIVE TO NO .8 PLUG, BREATHER HOLE PING, REAR FLANGE OIL SEAL - CRANKSHAFT PACKING - OIL SEAL DIPSTICK TUBE, DIPSTICK 0 RING, TUBE CLIP, TUBE SCREW, 10 UNC X 9/16CLAMP, BRACKET TUBE SCREW, 1/4- UNF X 3/8SPRING WASHER
* - PART OF CYLINDER BLACK GASKET/SEALS KIT N/I - NOT ILLUSTRATED
QUANTITY 1 8 4 2 1 10 2 2 2 1 2 1* 2* 1 1 1* 1 1 1 1 1
118 REMARKS
I
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION E10
DESCRIPTION : ENGINE - 350I - MOUNTING BRACKETS
I
COMMENTS : ALL MODELS. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23
PART NO . 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E
199A 200A 201A 202A 203A 204A 205A 206A 207A 208A 209A 210A 211A 203A 204A 206A 207A 201A 202A 218A 219A 220A 221A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
MOUNTING BRACKET - L .H . MOUNTING BRACKET - R .H . BOLT 7/16UNC X 1" BRACKET/BLOCK LOWER SPRING WASHER BOLT 5/16UNC X 3/4" BRKT/BLOCK UPPER SPRING WASHER ENGINE MOUNTING RUBBER - FRONT WASHER - PLAIN NYLOC NUT - M10 ENGINE MOUNTING RUBBER - REAR WASHER - PLAIN - RUBBER MOUNTING WASHER - SPRING - RUBBER MOUNTING NUT - RUBBER MOUNTING BOLT - 5/16 UNC X 3/4" BRKT/BLACK UPPER WASHER - SPRING WASHER - PLAIN - RUBBER TO BRACKET NYLOC NUT - M10 BOLT 7/16UNC X 1" BRACKET/BLOCK LOWER SPRING WASHER NUT - RUBBER MOUNTING WASHER - PLAIN WASHER -PALIN BOLT - CHASSIS TO RUBBER MOUNT
1 1 2 4 1 2 2 2 2 2 4 4 4 1 2 2 2 2 2 4 2 2 4
119 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION Ell
DESCRIPTION : ENGINE - 350I & 390/420 - PISTONS COMMENTS :350I ROVER VITESSE INJECTED VEER UNIT . 390/420 PISTONS TVR. DATE OF ISSUE - 1/5/86 IT;T
PART NO .
DATE REVISED
DRAWING REFERENCE
DESCRIPTION
QUANTITY
1 1
035E 222A 035E 223A
PISTON & RINGS ASSEMBLY 350 STD . PISTON & RINGS ASSEMBLY 350 0 .020" 0/S
8 8
1 2 2
039E 771A 035E 224A 035E 225A
PISTON & RINGS ASSEMBLY 390/420 KIT - PISTON RINGS 350I STANDARD KIT - PISTON RINGS 350 0 .020" 0/S
8 8 8
2 3 3 4 5 6 6 6
039E 035E 039E 035E 035E 035E 035E 035E
KIT - PISTON RINGS 390/420 CONNECTING ROD & CAP ASSEMBLY CONNECTING ROD & CAP ASSEMBLY BOLT NUT KIT - CONNECTING ROD BEARINGS KIT - CONNECTING ROD BEARINGS KIT - CONNECTING ROD BEARINGS
6
039E 774A
772A 226A 773A 227A 228A 229A 230A 231A
8 8 8 16 16 - 350I 1 0 .010"0/S 1 0 .020"0/S 1 - 350 - 420
KIT - CONNECTING ROD BEARINGS - 420
1
120 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION Ell
DESCRIPTION : ENGINE - 350I & 390/420 - PISTONS COMMENTS :350I ROVER VITESSE INJECTED VEE8 UNIT . 390/420 PISTONS TVR. DATE OF ISSUE - 1/5/86 ITEM
PART NO .
DATE REVISED
DRAWING REFERENCE
DESCRIPTION
QUANTITY
1 1
035E 222A 035E 223A
PISTON & RINGS ASSEMBLY 350 STD . PISTON & RINGS ASSEMBLY 350 0 .020" 0/S
8 8
1 2 2
039E 771A 035E 224A 035E 225A
PISTON & RINGS ASSEMBLY 390/420 KIT - PISTON RINGS 350I STANDARD KIT - PISTON RINGS 350 0 .020" 0/S
8 8 8
2 3 3 4 5 6 6 6
039E 035E 039E 035E 035E 035E 035E 035E
KIT - PISTON RINGS 390/420 CONNECTING ROD & CAP ASSEMBLY CONNECTING ROD & CAP ASSEMBLY BOLT NUT KIT - CONNECTING ROD BEARINGS KIT - CONNECTING ROD BEARINGS KIT - CONNECTING ROD BEARINGS
6
039E 774A
772A 226A 773A 227A 228A 229A 230A 231A
8 8 8 16 16 - 350I 1 0 .010"0/S 1 0 .020"0/S 1 - 350 - 420
KIT - CONNECTING ROD BEARINGS - 420
1
120 REMARKS
SECTION E12
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION : ENGINE - 350I & 390/420 - CRANKSHAFT
COMMENTS :350I ROVER VITESSE INJECTED VEE8 UNIT . 420 CRANKSHAFT TVR DATE OF ISSUE - 1/5/86 DATE REVISED ITEM 1 1 2 3 4 5 5 5 5 6 7 8 9 10 11 12 12 12 12 13 14 15
PART NO . 035E 039E 035E 035E 035E 035E 035E 035E 039E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E
232A 775A 233A 234A 235A 236A 237A 238A 776A 239A 240A 241A 242A 243A 244A 245A 246A 247A 248A 249A 250A 251A
DESCRIPTION
DRAWING REFERENCE 121 QUANTITY REMARK
CRANKSHAFT - 3501 CRANKSHAFT - 420 SE BUSH - REAMED - MANUAL GEARBOX ONLY SPROCKET - CRANKSHAFT KEY - SPROCKET/CRANKSHAFT KIT - CRANKSHAFT BEARINGS - 350 STD . KIT - CRANKSHAFT BEARINGS - 0 .010-U/S KIT - CRANKSHAFT BEARINGS - 0 .020-U/S KIT - CRANKSHAFT BEARINGS - 420 STD . DAMPER & PULLYS ASSEMBLY PULLEY, WATER PUMP & ALTERNATOR REINFORCING PLATE PULLEY - STEERING PUMP BOLT - 5/16UNF X 1 5/8NUT - 5/16" UNF BALANCE WEIGHT - 0 .18 OZ BALANCE WEIGHT - 0 .36 OZ BALANCE WEIGHT - 0 .54 OZ BALANCE WEIGHT - 0 .72 OZ BOLT - DAMPER/SPROCKET/CRANKSHAFT PLAIN WASHER PLAIN WASHER FOR ITEM 10/11
1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 2 A/R A/R A/R A/R 1 1 1
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
E13
DESCRIPTION : ENGINE - 350I & 390/420 - SUMP COMMENTS : ROVER VITESSE INJECTED VEE8 UNIT . ALSO TVR 390/420 MODELS. DATE OF ISSUE - 1/5/86 ITEM 1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 30
PART NO . 035E 252A 042E 795A 035E 253A 035E 254A 035E 255A 035E 256A 035E 257A 035E 258A 035E 259A 035E 260A 035E 261A 035E 262A 035E 263A 035E 264A 035E 265A 035E 266A 035E 267A 035E 268A 035E 269A 035E 270A 035E 271A 035E 272A 035E 273A 035E 274A 035E 275A 035E 276A 035E 277A 035E 278A 035E 279A N .P .N .
DATE REVISED
DRAWING REFERENCE
DESCRIPTION
QUANTITY
CRANKCASE SUMP - 30/390 ONLY CRANKCASE SUMP - 420 ONLY JOINT - WASHER, DRAIN PLUG DRAIN PLUG - 1/2- BSP SEALING WASHER GASKET - SUMP TO BLOCK BOLT & WASHER, 5/16- UNC X 11/16BOLT & WASHER - SUMP REAR REINFORCING STRIP OIL SCREEN HOUSING C/W STRAINER GASKET - OIL SCREEN HOUSING SCREW, 1/4- UNC X 3/4- HOUSING/BLOCK SPRING WASHER OIL SCREEN STEADY BRACKET - SCREEN HOUSING SCREW, 5/16- UNF X 5/8- HOUSING/BRACKET PLAIN WASHER SPRING WASHER NUT - 5/16- UNF STUD - 5/16- UNF/UNC THRUST WASHER DISTANCE PIECE THRUST WASHER SPRING WASHER NUT - 5/15- UNF BAFFLE PLATE SCREW, 1/4- UNC X 5/8- BAFFLE/BLACK SPRING WASHER PLAIN WASHER SENSOR - NOT USED BY TVR
* - PART OF CYLINDER BLOCK GASKET/SEALS KIT
1 1 1* 1 1* 1* 14 2 1 1 1* 2 2 1 1 1 1 1 1 1 1 1 1 1 1 1 6 6 6 1
122 PRICE
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
E14
DESCRIPTION : ENGINE - 350I & 390/420 - CAMSHAFT COMMENTS : 3501 ROVER VITESSE INJECTED VEE8 UNIT . 390/420 CAMSHAFT TVR. DATE OF ISSUE - 1/5/86 ITEM 1 1 2 3 4 5 6 7 8
PART NO . 035E 039E 035E 035E 035E 035E 035E 035E 035E
280A 777A 281A 282A 283A 284A 285A 286A 287A
DATE REVISED DESCRIPTION
CAMSHAFT - 350I CAMSHAFT - 390/420 CHAINWHEEL TIMING CHAIN KEY SPACER GEAR - DISTRIBUTOR DRIVE PLAIN WASHER BOLT - UNF
DRAWING REFERENCE QUANTITY 1 1 1 1 1 1 1 1 1
123 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
E15
DRAWING REFERENCE
124
DESCRIPTION : ENGINE - 350I & 390/420 - FRONT COVER. COMMENTS :350I ROVER VITESSE INJECTED VEE8 UNIT. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 7 7 8 9 10 11 12 13 14
PART NO . 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E
288A 289A 290A 291A 292A 293A 294A 295A 296A 297A 298A 299A 300A 301A 302A 303A
DATE REVISED DESCRIPTION
QUANTITY
COVER ASSEMBLY - TIMING CHAIN OIL SEAL DOWEL - WATER PUMP DOWEL PIN GASKET - COVER TO BLOCK DOWEL BOLT, 5/16- UNC X 4 1/4BOLT, 5/16- UNC X 3SCREW, 5/16- UNC X 1 1/8PLAIN WASHER SPRING WASHER NUT - 5/16- UNC TIMING POINTER SCREW, 1/4- UNC X 5/8-, POINTER/COVER SPRING WASHER PLAIN WASHER
* - PART OF CYLINDER BLOCK GASKET & SEALS KIT .
1 1* 2 2 1* 2 1 1 2 3 2 1 1 2 2 2
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
E16
DRAWING REFERENCE
125
DESCRIPTION : ENGINE - 350I & 390/420 - WATER PUMP. COMMENTS : 350I ROVER DATE OF ISSUE - 1/5/86 ITEM 1 2 3 3 4 4 5 5 5 6 N/I N/I 8 9 10 11
PART 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E
VITESSE INJECTED VEE 8 UNIT. DATE REVISED DESCRIPTION
NO .
304A 305A 306A 307A 308A 309A 310A 311A 312A 313A 314A 315A 316A 317A 318A 319A
QUANTITY
WATER PUMP ASSEMBLY GASKET - PUMP TO BLACK BOLT, 1/4- UNC X 1 1/8BOLT, 5/16" UNC X 1 1/4PLAIN WASHER - 1/4PLAIN WASHER - M8 BOLT, 5/16- UNC X 4 3/4BOLT, 5/16- UNC X 51/2SCREW, 3/8- UNC X 1 1/8PLAIN WASHER SPRING WASHER, 5/16SPRING WASHER, 3/8PULLEY, WATER PUMP BOLT, 1/4- UNF X 9/16- - PULLEY/PUMP SPRING WASHER V BELT - WATER PUMP
* - PART OF CYLINDER
BLACK
GASKET & SEALS
KIT
1 1* 5 1 5 1 1 3 1 3 1 1 1 3 3 1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
E17
DESCRIPTION : ENGINE - 350I & 390/420 - DIAGNOSTIC TIMING. COMMENTS : 350I ROVER VITESSE INJECTED VEE 8 UNIT. DATE OF ISSUE ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16
PART NO . 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E
320A 321A 322A 323A 324A 325A 326A 327A 328A 329A 330A 331A 332A 333A 334A 335A
DATE REVISED
DRAWING REFERENCE 126
DESCRIPTION SENSOR - DIAGNOSTIC TIMING CAP - SENSOR BRACKET, SENSING UNIT SCREW, 10 UNC X 1/2-, UNIT/BLACK SPRING WASHER BRACKET - SENSOR SPRING WASHER SCREW, M4, CONNECTOR/BRACKET PLAIN WASHER SPRING WASHER NUT - M4 COVER, SENSOR LEAD BRACKET SCREW, NO . 10 X 1/4-, COVER/BRACKET P CLIP, HARNESS/BRACKET SCREW, NO . 8 X 3/8FAN DISC WASHER
QUANTITY 1 1 1 1 1 1 1 2 2 2 2 1 1 1 1 1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
E18
DESCRIPTION :ENGINE - 350I & 390/420 - OIL PUMP. COMMENTS : 3501 ROVER VITESSE INJECTED VEE 8 UNIT - MODIFIED BY TVR. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 8 8 9 9A 10 10A 11 12 13 14 15 16 17 18 19 N/I N11 N/I N/I N/I N/I
PART NO . 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 025N 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E
336A 337A 338A 339A 340A 341A 342A 343A 344A 345A 346A 085A 102A 107A 103A 104A 144A 101A 100A 350A 099A 105A 174A 353A 354A 355A 356A 357A 358A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION
QUANTITY
SHAFT & GEAR ASSEMBLY GEAR DRIVEN OIL PUMP COVER ASSEMBLY REPAIR KIT - RELIEF VALVE JOINT WASHER JOINT WASHER GASKET - PUMP COVER BOLT, 1/4- UNC X 7/8BOLT, 1/4- UNC X 1 1/4BOLT, 1/4- UNC X 1 9/16" SWITCH - OIL PRESSURE WARNING LIGHT SWITCH - OIL PRESSURE GAUGE OIL PUMP SANDWICH PLATE OIL PUMP SANDWICH PLATE GASKET SEALING RUBBER - COVER PLAATE COVER PLATE - OIL SANDWICH PLATE ADAPTOR UNION - SANDWICH PLATE HOSE - SANDWICH PLATE/FILTER - 11 1/2HOSE - SANDWICH PLATE/FILTER - 10 1/2ADAPTOR UNION - REMOTE FILTER MOUNTING BRACKET - REMOTE FILTER HOUSING - REMOTE FILTER OIL FILTER - * TVR SPECIAL* ADAPTOR TO BRACKET NUT ADAPTOR TO BRACKET WASHER ADAPTOR TO BRACKET BOLT BRACKET TO BODYSHELL NUT BRACKET TO BODYSHELL WASHER BRACKET TO BODYSHELL BOLT
* - PART OF CYLINDER BLOCK GASKET/SEALS KIT .
1 1 1 1 1* 1* 1* 3 2 1 1 1 1 1 1 1 2 1 1 2 1 1 1 2 2 2 2 2 2
116 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
E19
DRAWING REFERENCE
127
DESCRIPTION : ENGINE - 350I & 390/420 - CYLINDER HEAD. COMMENTS : 350I ROVER VITESSE INJECTED VEE 8 UNIT. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 3 4 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 18
PART NO . 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 039E
359A 360A 361A 362A 363A 364A 365A 366A 367A 368A 369A 370A 371A 372A 373A 374A 375A 376A 377A 378A 778A
DATE REVISED DESCRIPTION
QUANTITY
CYLINDER HEAD ASSEMBLY VALVE GUIDE VALVE SEAT INSERT - INLET - STANDARD VALVE SEAT INSERT - INLET - 0 .010 . 01S VALVE SEAT INSERT - EXHAUST - STANDARD VALVE SEAT INSERT - EXHAUST - 0 .010 11 01S CORE PLUG CUP PLUG EXHAUST VALVE INLET VALVE SEAL - INLET VALVE VALVE SPRING CAP - VALVE SPRINGS SPLIT COTTERS DOWEL, HEAD TO BLOCK BOLT, 7/16- - 14 BOLT, 7/16- - 14 BOLT, 7/16- - 14 PLAIN WASHER GASKET - HEAD TO BLACK - 350I MODELS GASKET - HEAD TO BLACK 390/420 SPECIAL
* - PART OF CYLINDER HEAD GASKET/SEALS KIT
2 16 8 8 8 8 4 4 8 8 8 16 16 32 4 8 14 6 28 2* 2
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION E20
DESCRIPTION : ENGINE - 350I & 390/420 - ROCKER SHAFT. COMMENTS : 350I ROVER VITESSE INJECTED VEE 8 UNIT. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11
12 13
PART NO . 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E
379A 380A 381A 382A 383A 384A 385A 386A 387A 388A 389A 390A 391A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION ROCKER SHAFT ASSEMBLY SHAFT ROCKER ASSEMBLY - RIGHT HANDED ROCKER ASSEMBLY - LEFT HANDED BRACKET SPRING SPRING - SHAFT ENDS PLAIN WASHER SPLIT PIN
PLUG - SHAFT ENDS BOLT, 3/8" UNF BRACKET/HEAD PUSH ROD HYDRAULIC TAPPET
QUANTITY 2 2 8 8 8 6
4 4 4 4
8 16 16
128 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION E21
DESCRIPTION : ENGINE - 3501 & 390/420 - ROCKER COVERS. COMMENTS : 3501 ROVER VITESSE INJECTED VEE 8 UNIT. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23
PART NO . 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E
392A 393A 394A 395A 396A 397A 398A 399A 400A 401A 402A 403A 404A 405A 406A 407A 408A 409A 410A 411A 412A 413A 414A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION ROCKER COVER ASSEMBLY - L .H . OIL FILLER NECK SCREW, NO . 6 X 3/8- BAFFLE/COVER GASKET - COVER/HEAD - L .H . CAP - OIL FILLER SEAL - CAP MOUNTING PLATE - FILTER FILTER CAP - FILTER RETAINER - H .T . LEADS SCREW, 10 UNC X 3/8- RETAINER/COVER ROCKER COVER ASSEMBLY - R .H . VENTILATOR/FLAME TRAP SEAL SCREW, NO . 6 X 3/8-, BAFFLE/COVER GASKET - COVER/HEAD - R .H . RETAINER - H .T . LEAD SCREW, 10 UNC X 1/2- RETAINER/COVER LABEL - TVR SCREW, 1/4- UNC X 7/8-, COVERS/HEAD SCREW, 1/4- UNC X 5/16SPRING WASHER PLAIN WASHER
* - PART OF CYLINDER HEAD GASKET/SEALS KIT.
UANTIY Q
129
REMARKS 1 1 4 1 1 1* 1 1* 1 2 2 1 1 1* 1
1* 1 1 2 4 4 8 8
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION E22
DESCRIPTION : ENGINE - 350I & 390/420 - INLET MANIFOLD. COMMENTS : 350I ROVER VITESSE INJECTED VEE 8 UNIT. DATE OF ISSUE - 1/5/86 DATE REVISED ITEM
PART NO . 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035N 025N 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E
415A 416A 417A 418A 419A 420A 421A 422A 423A 424A 095A 035A 426A 427A 428A 429A 430A 431A 432A 433A 434A 435A 436A 437A 438A 439A 440A 441A 442A 443A 444A 445A
DESCRIPTION
DRAWING
REFERENCE 130 QUANTITY REMARKS
INLET MANIFOLD ASSEMBLY 1 PIPE ASSEMBLY - HEATER FEED 1 DOWEL, MANIFOLD/RAM HOUSING 2 FERRULE, BY PASS PIPE 1 SPRING PIN 1 THERMOSTAT - 88 DEGREES 1 ELBOW, WATER OUTLET 1 GASKET - ELBOW 1* SCREW, 5/16" UNF X 7/8-, ELBOW INLET 2 SPRING WASHER 2 TRANSMITTER - WATER TEMPERATURE - VDO 1 TRANSMITTER - WATER TEMPERATURE - SMITHSI THERMO TIME SWITCH 1 TEMPERATURE SENSOR - E .C .U . 1 SEALING WASHER 1* AUXILIARY AIR DEVICE 1 SCREW, 1/4- UNC X 3/42 PLAIN WASHER 2 SPRING WASHER 2 GASKET - MANIFOLD 1* SEAL 2* CLAMP 2 BOLT, 5/16- UNC, CLAMP/BLOCK 2 BOLT, 3/8- UNC X 1 1/2- MANIFOLD/BLACK 10 BOLT, 3/8- UNC X 22 PLAIN WASHER 12 PIPE, WATER OUTLET, HEATER 1 CLIP, PIPE/MANIFOLD 1 SCREW, 1/4- UNC X 5/82 SPRING WASHER 2 HOSE, THERMO BY PASS 1 CLIP 2
* - PART OF CYLINDER HEAD GASKET/SEAL KIT
SECTION
E23
DRAWING REFERENCE
131
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION : ENGINE - 350I & 390/420 - ACCELERATOR LINKAGE. COMMENTS : 350I ROVER VITESSE INJECTED VEE 8 UNIT. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 N/I N/I N/I
PART NO . 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E
446A 447A 448A 449A 450A 451A 452A 453A 454A 455A 456A 457A 458A 459A 460A 461A 462A 463A 464A 465A 466A 467A 468A 469A 470A 471A 472A 473A 474A 475A 476A 477A 478A 479A 480A 481A 482A 483A 484A 485A486A 487A 488A 489A
DATE REVISED DESCRIPTION
QUANTITY
BRACKET - THROTTLE .CABLE COUNTERSHAFT ASSEMBLY DOG PIN BRACKET ASSEMBLY - COUNTERSHAFT BUSH SCREW, 5/16- UNC X 5/8-, BKT/MANIFOLD PLAIN WASHER PLAIN WASHER CIRCLIP LEVER - THROTTLE SPRING BOLT, 10 UNF X 3/4-, LEVER/COUNTERSHAFT PLAIN WASHER NUT - 10 UNF SPRING - THROTTLE RETURN THROTTLE LINK ASSEMBLY SPRING WASHER - LINK/LEVERS NUT - 10 UNF THROTTLE LEVER BOLT, 1OUNF X 3/4-, LEVER/SHAFT PLAIN WASHER NUT - 10 UNF PLAIN WASHER SPHERICAL HOUSING SPHERICAL BUSH BOLT, 10 UNF X 7/16-, HOUSING/BRACKET SPRING WASHER NUT - 10UNF BRACKET - COUPLING SHAFT SCREW, 1/4- UNF X 5/8-, BKT/BKT PLAIN WASHER SPRING - THROTTLE RETURN FERRULE - SPRING LOCATION SHAFT ASSEMBLY - THROTTLE COUPLING CIRCLIP NUT - THROTTLE SPINDLE TAB WASHER STOP LEVER BRACKET - THROTTLE CONTROL SCREW, 1/4- UNC X 1/2-, BKT/PLENUM SCREW, 1/4- UNC X 5/8SPRING WASHER BRACKET ASSEMBLY - FUEL PIPE CLIP - FUEL PIPE SPLIT PIN
1 1 1 1 1 2 2 1 1 1 1 1 1 1 1 2 2 1 1 1 1 1 2 1 2 2 2 1 2 1 2 1 1 1 1 1 1 1 2 2 4 I I 1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION E24
DESCRIPTION : ENGINE - 350I & 390/420 - RAM PIPE HOUSING. COMMENTS : 3502 ROVER VITESSE INJECTED VEE 8 UNIT. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8
PART NO . 035E 035E 035E 035E 035E 035E 035E 035E
490A 491A 492A 493A 494A 495A 496A 497A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION
QUANTITY
RAM PIPES HOUSING ASSEMBLY RAM PIPES CUP PLUG BOLT, 5/16" UNC X 2 1/4", HOUSING/MFOLD PLAIN WASHER NON RETURN VALVE - BRAKE SERVO PLUG JOINT WASHER
* - PART OF CYLINDER HEAD GASKET/SEALS KIT.
1 8 1 6 6 1 1 2*
132 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
E25
DESCRIPTION : ENGINE - 350I & 390/420 - FUEL INJECTION. COMMENTS : 350I ROVER VITESSE INJECTED VEE 8 UNIT. DATE OF ISSUE - 1/6/86 ITEM
_
1 2 3 4 5 6 7 8 9 10 11 12 13 13 14 15 16 17 18 19 20 21 22 22 23 24 25 26 27
PART NO . 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 042E 035E 035E 035E 035E 035E 035E 035E 035E 035E 039E 035E 035E 035E 035E 035E
498A 499A 500A 501A 502A 503A 504A 505A 506A 507A 508A 509A 510A 662A 511A 512A 513A 514A 515A 516A 517A 518A 519A 780A 520A 521A 522A 523A 524A
DATE REVISED DESCRIPTION
DRAWING REFERENCE 133 QUANTITY
FUEL FEED PIPE ASSEMBLY SCREW, NO . 8 X 3/8" HOSE - FEED PIPE/RAIL CLIP FUEL RAIL ASSEMBLY - L .H . FUEL RAIL ASSEMBLY - R .H . HOSE - FUEL RAIL CLIP HOSE - FUEL RETURN CLIP HOSE - RAIL/COLD START INJECTOR CLIP INJECTOR - 390/420 INJECTOR - 420 SEAL RING - UPPER SEAL RING - LOWER MOUNTING PLATE - INJECTORS SCREW, 1/4" UNC X 3/4" SPRING WASHER CLAMP PLATE SCREW, 1/4" UNC X 1/2",PLATE/MTG . PLATE HEAT SHIELD, EGR PIPE - NOT USED ON TVR PRESSURE REGULATOR - 350I PRESSURE REGULATOR - 390/420 NUT, M12, REGULATOR/BRACKET BRACKET - REGULATOR SCREW, 1/4" UNC X 1/2"BRACKET/M'FOLD SPRING WASHER TUBING, REGULATOR VACUUM/PLENUM
1 1 1 2 1 1 2 4 1 2 1 2 8 8 8* 8* 4 8 8 4 8 1 1 1 1 1 1 1 A/R
* - PART OF CYLINDER HEAD GEAKET/SEALS KIT .
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
E26
DRAWING REFERENCE
134
DESCRIPTION : ENGINE - 350I & 390/420 - PLENUM CHAMBER. COMMENTS :350I ROVER VITESSE INJECTED VEE 8 UNIT. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
PART NO . 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E .035E 035W
525A 526A 527A 528A 529A 530A 531A 532A 533A 534A 535A 536A 537A 538A 539A 540A 541A 542A 543A 544A 545A 546A 547A 548A 549A 175A 088A 090A
DATE REVISED DESCRIPTION
QUANTITY
PLENUM CHAMBER ASSIMBLY CUP PLUG CONNECTOR - VACUUM THROTTLE SPINDLE BUSH SEAL THROTTLE DISC SCREW, DISC/SPINDLE INJECTOR - COLD START GASKET - INJECTOR SCREW, M6 X 12MM SPRING WASHER DECELERATION VALVE - ADJUSTED BY TVR JOINT WASHER - DECEL . VALVE SCREW, 5/16" UNC X 3/4" SPRING WASHER SCREW, SLOW RUNNING MOUNTING PLATE - POTENTIOMETER SCREW, 1/4" - PLATE/PLENUM SPRING WASHER POTENTIOMETER SCREW, M4 X 14 MM PLAIN WASHER SCREW, 5/16"UNC X 3"PLENUM/RAM HOUSING PLAIN WASHER BLANKING PLUG - IDLE SETTING INDUCTION HOSE, METER/PLENUM JUBILEE CLIP, 60/80MM
* - PART OF CYLINDER HEAD GASKET/SEALS KIT .
1 2 1 1 2 2* 1 2 1 1* 2 2 1 1* 3 3 1 1 3 3 1 3 3 6 6 2 1 2
REMARKS
SECTION E27
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION : ENGINE - 350I & 390/420 - PLENUM HOSES. COMMENTS : 3501 ROVER VITESSE INJECTED VEE 8 UNIT. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16
PART NO . 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E
551A 552A 553A 554A 555A 556A 557A 558A 559A 560A 561A 562A 563A 564A 565A 566A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
PIPE - AUXILIARY AIR DEVICE/DECEL VAL . CLIP - PIPE/RAM HOUSING SCREW, M6 X 12MM, CLIP/HOUSING SPRING WASHER HOSE, PIPE/DECEL . VALVE HOSE, PLENUM/PIPE HOSE, A .A .D ./PIPE HOSE, A .A .D ./PLENUM HOSE CLAMP HOSE, PIPE/VALVE - AIR CONDITION ONLY SOLENOID OPERATED AIR VALVE - A/C ONLY SHOULDERED SCREW - A/C ONLY SPRING WASHER - A/C ONLY NUT, 5/16" UNC, A/C ONLY HOSE, VALVE/PLENUM - A/C ONLY HOSE, BREATHER/PLENUM
1 2 2 2 1 1 1 1 3 1 1 1 1 1 1 1
135 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
E28
DESCRIPTION : ENGINE - 3501 & 390/420 - GASKET KITS. COMMENTS : 350I ROVER VITESSE INJECTED UNIT . 390/420 HEAD GASKET TVR'S DATE OF ISSUE - 1/5/86 ITEM
PART NO .
DATE REVISED
DRAWING REFERENCE 136
DESCRIPTION
QUANTITY
1 2
035E 567A 035E 568A
GASKET & SEALS KIT - CYLINDER BLOCK GASKET & SEALS KIT - CYLINDER HEAD
1 1
N/I
039E 778A
GASKET - CYLINDER HEAD - 390 & 420
2
FOR A COMPLETE ENGINE REBUILD USE BOTH KITS .
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION E29
DESCRIPTION : ENGINE - 350I & 390/420 - ENGINE ELECTRICS - ALTERNATOR. COMMENTS : LUCAS A133-65 ASSEMBLY. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
PART NO . 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E
569A 570A 571A 572A 573A 574A 575A 576A 577A 578A 579A 580A 581A 582A 583A
DATE REVISED DESCRIPTION
ALTERNATOR ASSEMBLY - A133-65 KIT - BRUSHES REGULATOR RECTIFIER SURGE PROTECTOR COVER KIT - DRIVE END BEARING KIT - REAR BEARING KIT - SCREWS KIT - SPACERS KIT - TERMINALS KIT - SUNDRY PARTS SUPRESSION CAPACITOR FAN PULLEY
DRAWING REFERENCE QUANTITY 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
137 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
E30
DESCRIPTION : ENGINE - 3501 & 390/420 - ALTERNATOR MOUNTINGS. COMMENTS : SPECIAL TVR MOUNTINGS. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26
PART NO . 035E 025W 025W 025W 025W 025W 025W 025W 025W 025W 025W 025W 025W 025W 035E 025W 025W 035E 025W 025W 025W 025W 025W 025W 025W 025W
092A 096A 098A 097A 095A 098A 097A 094A 040A 091A 099A 040A 091A 039A 093A 100A 040A 787A 009A 006A 093A 021A 092A 091A 040A 039A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
MOUNTING BRACKET - . ALTERNATOR 1 1 BOLT, LOWER BRACKET, 3/8"UNC X 3 1/2" SPRING WASHER, 3/8" 1 PLAIN WASHER, 3/8" 1 1 BOLT, UPPER BRACKET, 3/8"UNC X 2 1/4" 1 SPRING WASHER, 3/8" PLAIN WASHER, 3/8" 1 BOLT, UPPER BRACKET, 5/16"UNC X 2 1/4" 1 SPRING WASHER, 5/16" 1 1 PLAIN WASHER, 5/16" BOLT,ALTERNATOR MTG . 5/16"UNC X 2 1/2" 1 2 SPRING WASHER, 5/16" PLAIN WASHER, 5/16" 2 NUT, 5/16" PLAIN 1 SPACER - ALTERNATOR 1 BOLT,ADJUSTING LINK/BLOCK,5/16UNC X1/12 1 SPRING WASHER, 5/16" 1 1 ADJUSTING LINK - ALTERNATOR BOLT,ADJUSTER, M8 X 35 1 2 PLAIN WASHER, M8 SPRING WASHER, M8 1 1 NUT, PLAIN, K8 BOLT, ALTERNATOR MTG . 5/16" UNC X 2 1/2"1 PLAIN WASHER, 5/16" 2 1 SPRING WASHER, 5/16" NUT, PLAIN, 5/15" 1
138 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION E31
DESCRIPTION : ENGINE - 350I - IGNITION COIL. COMMENTS :350I TO END OF 1983 - LUCAS 2 C .E . CONSTANT ENERGY IGNITION UNIT. DATE OF ISSUE - 1/5/86 ITEM
PART NO .
DATE REVISED
DRAWING REFERENCE
DESCRIPTION
QUANTITY
1 2 3 4 5 6 7
035E 035E 025W 025W 025W 025W 025W
085A 166A 015A 003B 009A 006A 005A
COIL & AMPLIFIER ASSEMBLY COIL M6 X 20 SETSCREW M6 SPRING WASHER M8 X 35 BOLT - UNIT TO BODY M8 PLAIN WASHER M8 NYLOC NUT
1 1 2 2 2 2 2
8 9 10 11 12 13 14 15 16 17 18 19
035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E
781A 597A 596A 592A 782A 783A 784A 785A 585A 586A 594A 595A
DISTRIBUTOR ASSEMBLY - OPUS TYPE CLIP - TUBE/BLOCK VACUUM TUBE TO PLENUM VACUUM UNIT CAP - DISRTIBUTOR ROTOR ARM INSULATING COVER PICK UP AND BASE PLATE 0 RING DRIVEN GEAR ASSEMBLY CLAMP, DISTRIBUTOR/FRONT COVER SCREW, 3/8" UNC X 1 1/2"
1 1 1 1 1 1 1 1 1* 1 1 1
* PART OF CYLINDER BLOCK GASKET/SEALS KIT
142 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION E32
DESCRIPTION : ENGINE 350I & 390/420 - IGNITION COIL & DISTRIBUTOR. COMMENTS : 350I ROVER 1984 ON WITH COMBINED DISTRIBUTOR/IGNITION MODULE. DATE OF ISSUE - 1/5/86 ITEM 1 1 N/I 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
PART NO . 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 025W 025W 025W 025W 035W 025M
584A 660A 661A 585A 586A 587A 588A 589A 590A 591A 592A 594A 595A 596A 597A 166A 020A 006A 007A 005A 603A 138A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION DISTRIBUTOR ASSEMBLY - EUROPEAN DISTRIBUTOR ASS . - SWEDISH & SWISS VACUUM DELAY VALVE 0 RING DRIVEN GEAR ASSEMBLY CAP ROTOR ARM INSULATING COVER PICK UP AND BASE PALTE MODULE VACUUM UNIT CLAMP, DISTRIBUTOR/FRONT COVER SCREW, 3/8" UNC X 1 1/2" VACUUM TUBE TO PLENUM CLIP, TUBE/BLOCK COIL BOLT, M8 X 40 COIL TO BODY M8 PLAIN WASHER M8 , STAR WASHER M8 NUT - NYLOC SUPRESSOR - COIL EARTH STRAP - COIL TO ALTERNATOR
* PART OF CYLINDER BLOCK GASKET/SEALS KIT .
QUANTITY 1 1 1 1* 1 1 1 1 1 1 1 1 1 1 1 1 2 2 2 2 1 A/R
114 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION E32
DESCRIPTION : ENGINE - 350I & 390/420 - H .T . LEADS rowww'r q • IsnT ROVER VITESSE INJECTED VEE 8 UNIT. DATE OF ISSUE - 1/5/86 ITEM 1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21
PART NO . 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 035E 025M 025W 025W 025W 025W
604A 655A 605A 606A 607A 608A 609A 610A 611A 612A 613A 614A 615A 616A 617A 613A 786A 138A 090A 087A 088A 089A
DATE REVISED
DRAWING REFERENCE 139
DESCRIPTION H .T . LEAD KIT - U .K . SPECIFICATION H .T . LEAD KIT - EUROPEAN SPEC . SPARK PLUG - NIOY RETAINER - FIXED RETAINER - LOOSE CLIP EXTENSION PLATE SCREW, 10 UNF X 3/8" PLATE/CLIP SCREW, 10 UNP X 1/2" PLATE/CLIP SPRING WASHER NUT - 10 UNF SUPPORT BRACKET ASSEMBLY RETAINER, LEADS SCREW, 10 UNF X 1/2" PLAIN WASHER NUT - 10 UNF SHIELD - SUPRESSION EARTHING STRAP - SUPRESSION SHIELD SETSCREW, 2 BA X 15I44 PLAIN WASHER, 2 BA STAR WASHER, 2 BA NUT, 2 BA
QUANTITY 1 1 8 1 3 1 1 2 1 3 3 1 1 1 1 1 1 A/R 1 1 1 1
REMAB
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION E34
DESCRIPTION : ENGINE - 3501 & 390/420 - STARTER MOTOR. fr COMMENTS : 350I ROVER VITESSE INJECTED VEE 8 UNIT. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8
PART NO . 035E 035E 035E 035E 035E 035E 035E 039E
619A 620A 621A 622A 623A 624A 625A 779A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
STARTER MOTOR ASSEMBLY, LUCAS 3M100 SOLENOID BRUSH KIT SCREW, 3/8" UNC X 1 1/2", STARTER/BLOCK PLAIN WASHER SPRING WASHER BOLT, SOLENOID TO STARTER HEATSHIELD - 390/420 ONLY
1 1 1 2 2 2 2 1
140 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
E35
DESCRIPTION : ENGINE - 350I & 390/420 - FUEL INJECTION HARNESS r COMMENTS : AS 350I ROVER INJECTED VEE 8 UNIT . TVR'S RELAY & FUSE BOARD. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
PART NO . 035E 035E 035E 025W 042E 035E 025W 025W 025M 035E 025W 025W 025W 035E 035E 025W 125M 025M 025M 025M 025M 035E 035E 025W 035E 025W 025W 025W 035E 035T 035T
692A 627A 628A 077A 663A 087A 020A 006A 138A 089A 085A 007A 005A 110A 109A 084A 240A 200A 200A 202A 052A 442A 443A 046A 086A 086A 087A 089A 114A 015A 016A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
HARNESS, P .I . ENGINE P CLIP SCREW TIE WRAP - MEDIUM AIR FLOW METER - 420 ONLY AIR FLOW METER - 350/390 ONLY BOLT, M8 X 40, BRACKET/BODY M8 PLAIN WASHER, BRACKET/BODY EARTH STRAP, RESISTOR/METER/CHASSIS MOUNTING BRACKET - METER M8 PENNY WASHER - BRACKET/BODY M8 STAR WASHER, BRACKET/BODY M8 NYLOC NUT, BOLT, BRACKET/BODY BRASS TOP HAT, BRACKET/METER RUBBER GROMMET, BRACKET/METER BOLT, M8 X 30, BRACKET/METER FUSE BLOCK - INSIDE GLOVE BOX FUSE - 20AMP - FUEL PUMP FUSE - 20AMP - IGNITION COIL RELAY BLOCKS - FUEL INJECTION RELAYS RELAY - FUEL PUMP - LUCAS RELAY .- E .C .U . INJECTION - BOSCH RELAY - ECU REVERSE POLARITY, RED ROVER SELF TAPP SCREW - POWER RESISTOR/BODY POWER RESISTOR SETSCREW, 2BA X 40 MM, ECU MOUNTING PLAIN WASHER, 2BA - ECU MOUNTING NUT - 2BA, ECU MOUNTING ELECTRONIC CONTROL UNIT FUSE DIAGRAM LABEL ON GLOVE BOX LID RELAY DIAGRAM LABEL ON E .C .U .
1 4 4 4 1 1 2 10 A/R 1 6 4 2 3 3 3 2 1 1 3 1 1 1 2 1 3 6 3 1 1 1
212 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION E36
DESCRIPTION :ENGINE - 3501 & 390/420 - AIR FILTER ASSEMBLY. r COMMENTS : TVR ASSEMBLY FROM SERIES 1 TO CURRENT. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16
PART NO . 035E 094A 035W 090A 035E 088A 035E 788A 025W 009A 025W 006A 025W 005A 035E 789A N .P .N . N .P .N . 035E 159A 035E 087A 035E 161A 035E 160A 026W 022A 035E 162B
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
AIR CLEANER ASSEMBLY JUBILEE CLIP, 60/80 MM HOSE, CLEANER ASSEMBLY/AIR FLOW METER AIR FILTER BOLT, M8 X 35 - ASSEMBLY MOUNTING PLAIN WASHER - M8 NUT - NYLOC M8 AIR CLEANER ASSEMBLY - STAINLESS STEEL GASKET - PART OF AIR FLOW METER SET SCREW - PART OF AIR FLOW METER AIR CLEANER ASSEMBLY - BACKPLATE LOCKPLATE, PART OF AIR FLOW METER MOUNTING RODS - AIR CLEANER ASSEMBLY AIR CLEANER ASSEMBLY - FRONTPLATE LOCK NUTS, M6 DOME HEAD AIR FILTER
1 2 1 1 2 2 2 1 1 4 1 1 4 1 4 1
215 REMARKS EARLY 3501 CARS ONLY
INTERNAL FILTER CURRENT FILTER ASSEMBLY
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION F1
DESCRIPTION : GEARBOX - 2801 - 4 SPEED. p COMMENTS : EUROPEAN FORD GRANADA - "E" TRANSMISSION. DATE OF ISSUE - 1/5/86 ITEM
1 2 3 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
025F OO1A
TRANSMISSION - 4 SPEED
1
025F 020A 025F 008A 025F 007A 025F 022A 025F 016A 025F 017A 025F 015A 025F 013A 025F 014A 025F 012A 025F 333A 025F 334A 025F 028A 025F 335A 025F 337A 025F 336A 025F 027A 025F 338A 025F 030A 025F 339A 025F 340A 025F 341A 025F 342A 025F 343A 025F 005A 025F 004A 025F 021A 025F 029A 025F 025A 025F 344A 025F 345A 025F 023A 025F 024A 025F 026A 025F 009A 025F 071A 025W 006A• 025F O10A 025F 346A 025F 347A 025W 006A 025F 348A 025F 349A N .P .N . 025F 350A 025W 006A
BELL HOUSING - GEARBOX 1 WASHER - GEARBOX TO BELLHOUSING 8 BOLT, GEARBOX/BELLHOUSING - LONG 4 4 BOLT, GEARBOX/BELLHOUSING - SHORT BOLT, 1/4" X 3/4"UNC,SPEEDO . DRIVE RET . 1 WASHER SPRING, 1/4" SPEEDO . DRIVE RET . 1 RETAINER, SPEEDOMETER DRIVE 1 BEARING - SPEEDOMETER DRIVE 1 0 RING SPEEDOMETER DRIVE 1 SPEEDOMETER DRIVEN GEAR 1 DETENT BALLS 3 DETENT SPRINGS 3 GASKET - GEARBOX HOUSING TOP PLATE 1 COVER - GEARBOX HOUSING - TOP 1 WASHER 11 BOLT - COVERS TO HOUSING 11 GASKET - EXTENSION HOUSING/GEARBOX 1 EXTENSION HOUSING - GEARBOX 1 GASKET - EXTENSION HOUSING TOP COVER 1 COVER - EXTENSION HOUSING 1 BOLT, HOLLOW - REVERSE INTERIOCK 1 LOCKWASHER - REVERSE INTERIOCK 1 SPRING - REVERSE INTERIOCK 1 INTERLOCK BALL 1 KNOB - GEAR LEVER 1 GEAR LEVER ASSEMBLY 1 BOOT - GEAR LEVER 1 GASKET - GEAR LEVER BASE 1 BUSH - NYLON - GEAR LEVER BASE 1 SELECTOR HOUSING COVER 1 1 GASKET - SELECTOR HOUSING COVER BEARING - EXTENSION HOUSING 1 SEAL, OIL - EXTENSION HOUSING 1 2 UNIVERSAL JOINT - REPAIR KIT PROPELLOR SHAFT 1 4 NUT - PROPELLOR SHAFT/FINAL DRIVE 4 WASHER - PLAIN 4 BOLT - PROPELLOR SHAFT/FINAL FRIVE 1 ROLL PIN - REVERSE GEAR RELAY LEVER PRESSURE SPRING - REVERSE GEAR INTERLOCK1 1 WASHER - PLAIN 1 SWITCH - REVERSING LIGHT 1 COVER - REVERSING LIGHT SWITCH LEAD - REVERSING LIGHT SWITCH/LOOM 1 4 BOLT - EXTENSION HOUSING/GEARBOX WASHER - PLAIN 4
4 REMARKS
DATE OF ISSUE - 1/5/86 ITEM
DATE REVISED DESCRIPTION
PART NO .
DRAWINGNG REFERENCE QUANTITY
f
46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73
025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025W 025F 025W 025W 025W 025W 025F 025F 025E 025F 025F 025F 025F 025W
351A 352A 353A 354A 355A 356A 357A 358A 359A 360A 361A 362A 363A 364A 013A 006A 009A 0O6A 005A 101A 002A 365A 013A 366A 367A 368A 369A 006A
1 BEARING RETAINER GUIDE PIN 1 SELECTOR ROD 1 1 SELECTOR ROD BEARING SUPPORT SELECTOR RAIL C/W 1ST ./2ND . GEAR FORK 1 2 PLUNGER SELECTOR FINGER 1 1 INTERMEDIATE LEVER SELECTOR RAIL WITH REVERSE SELECTOR FORK1 SELECTOR RAIL C/W " 3RD ./4TH . GEAR FORK 1 4 SPEED GEARBOX CASING 1 1 OIL DRAIN PLUG OIL FILLER PLUG 1 6 BOLT - GEARBOX TO BELL HOUSING 6 WASHER - PLAIN GASKET - GEARBOX/BELL HOUSING 1 BOLT, M8 X 35 - GEARBOX TO CHASSIS 2 WASHER, M8 - PLAIN 2 NUT, M8 - NYLOC 2 1 BOLT, M12 X 25 - INSULATOR/GEARBOX INSULATOR 1 6 BOLT, BELLHOUSING/ENGINE WASHER - PLAIN 6 OIL SEAL - BEARING RETIANER 1 1 GASKET - DRIVE GEAR BEARING RETAINER 1 DRIVE GEAR BEARING RETAINER 4 BOLT,-DRIVE GEAR RETAINER/GEARBOX 4 WASHER - PLAIN
4 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION F2
DESCRIPTION : GEARBOX - 2801 - 4 SPEED. r COMMENTS : EUROPEAN FORD GRANADA - "E" TRANSMISSION GEAR COMPONENTS DATE OF ISSUE - 1/5/86 ITEM 1 2 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31
PART NO . 025F 374A 025F 375A 025F 376A 025F 377A 025F 378A 025F 379A 025F 380A 025F 381A 025F 382A 025F 383A 025F 384A 025F 385A 025F 386A 025F 387A 025F 388A 025F 389A 025F 390A 025F 391A 025F 392A 025F 393A 025F 394A 025F 395A 025F 396A 025F 397A 025F 398A 025F 399A 025F 400A 025F 401A 025F 402A 025F 403A 025F 404A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION CIRCLIP - INPUT DRIVESHAFT CIRCLIP GROOVED RACE BALL BEARING INPUT DRIVESHAFT NEEDLE ROOLER BEARING CIRCLIP SYNCHRONIZER RING - 3RD/4TH GEAR 3RD/4TH GEAR SYNCHRONIZER HUB 3RD . GEARWHEEL GEARBOX MAINSHAFT DRIVE BALL - SPEEDOMETER WORM GEAR 2ND . GEARWHEEL SYNCHRONIZER RING - 1ST/2ND GEARHUB 1ST/2ND GEAR SYNCHRONIZER HUB CIRCLIP 1ST . GEARWHEEL OIL SCOOP RING BEARING SUPPORT BALL BEARING SPACER RING SPEEDOMETER WORM GEAR LOCK PLATE MAINSHAFT NUT THRUST WASHER SPACER SHIM NEEDLE ROLLERS COUNTERSHAFT GEAR CLUSTER THRUST WASHER COUNTERSHAFT REVERSE GEAR IDLER GEAR IDLER GEAR SHAFT
QUANTITY 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 22 1 1 1 1 1
5 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
F3
DESCRIPTION : GEARBOX - 280I - 5 SPEED. r COMMENTS :EUROPEAN FORD GRANADA - "N" TRANSMISSION - FINIS 9 .1 DATE OF ISSUE - 1/5/86 ITEM
PART NO .
DATE REVISED
DRAWING REFERENCE
DESCRIPTION
QUANTITY
1 2 3 4 5 6 7 8 9 10 10A 11 12 13 14 15 16 17 18 19 20 21 22 23 24 24 25 26 27 28 29
025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F
084A 405A 406A 407A 408A 409A 410A 411A 412A 413A 414A 415A 416A 417A 418A 419A 420A 421A 422A 423A 424A 425A 426A 427A 102A 106A 428A 429A 430A 431A 432A
TRANSMISSION ASSEMBLY - 5 SPEED TRANSMISSION CASE TRANSMISSION CASE COVER GASKET - TRANSMISSION COVER BOLT & LOCKWASHER - COVER/CASE OIL SEAL - FRONT GASKET RETAINER - MAIN DRIVE GEAR BEARING BOLT & LOCKWASHER - RETAINER/CASE GASKET - REAR CASE/TRANSMISSION JOINT - REAR CASE/EXTENSION HOUSING EXTENSION HOUSING ASSEMBLY DOWEL GEAR SHIFT SHAFT BUSH PIN BUSH GEAR SHIFT SHAFT STOP BUSH - REAR OIL SEAL EXTENSION HOUSING - REAR PLUG - BLANKING BOLT - EXTENSION HOUSING/TRANSMISSION OIL FILLER PLUG SWITCH - REVERSE LIGHT SPEEDOMETER DRIVING GEAR SPEEDO . DRIVEN GEAR - 24 TOOTH SPEEDO . DRIVEN GEAR - 23 TOOTH COVER - SPEEDO . DRIVING GEAR OIL SEAL - DRIVING GEAR CIRCLIP - DRIVING GEAR PLUG REAR CASE - TRANSMISSION
1 1 1 1 10 1 1 1 4 1 1 1 1 1 1 1 1 1 1 1 6 1 1 1 1 1 1 1 1 1 1
N/I N/I N/I N/I N/I N/I
025F 025F 025F 025F 025F 025F
109A 433A 434A 435A 009A 026A .
GEAR LEVER ASSEMBLY KNOB - GEAR LEVER GEAR LEVER SELECTOR HOUSING COVER GASKET - SELECTOR COVER PROPELLOR SHAFT UNIVERSAL JOINT - REPAIR KIT
1 1 1 1 1 1
234 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
F4
DESCRIPTION : GEARBOX - 280I - 5 SPEED. r COMMENTS : EUROPEAN FORD GRANADA - "N" TRANSMISSION GEAR COMPONENTS DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45
PART NO . 025F 436A 025F 437A 025F 438A 025F 439A 025F 440A 025F 441A 025F 442A 025F 443A 025F 444A 025F 445A 025F 446A 025F 447A 025F 448A 025F 449A 025F 450A 025F 451A 025F 452A 025F 453A 025F 454A 025F 455A 025F 456A 025F 457A 025F 458A 025F 459A 025F 460A 025F 461A 025F 462A 025F 463A 025F 464A 025F 465A 025F 466A 025F 467A 025F 468A 025F 469A 025F 470A 025F 471A 025F 472A 025F 473A 025F 474A 025F 475A' 025F 476A 025F 477A 025F 478A 025F 479A 025F 480A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
1 BEARING - TRANSMISSION FLOAT 1 GEAR - TRANSMISSION MAIN DRIVE 1 BEARING ASSEMBLY A/R CIRCLIP - 2 .16/2 .50 MM CIRCLIP 1 1 MAIN TRANSMISSION SHAFT ASSEMBLY 1 GEAR - MAINSHAFT REVERSE 1 RING - TRANSMISSION 1ST & 2ND . CIRCLIP 1 1 GEAR TRANSMISSION - 2ND . SPEED THRUST WASHER 2 1 RING - THRUST WASHER RETAINER 1 GEAR - TRANSMISSION 3RD . SPEED 1 RING - TRANSMISSION 3RD & 4TH . SPEED 1 SPRING - SYNCHRONIZER - CIRCULAR 1 SYNCHRONIZER ASS . TRANS . 3RD & 4TH . A/R CIRCLIP - 1 .63/1 .85 MM SPRING - TRANSMISSION 1ST . & 2ND . SPEED 1 INSERT - TRANS . 1ST . & 2ND . SYNCHRONIZER1 1 INSERT - SYNCHRONIZER 1 NEEDLE BEARING ASSEMBLY 1 GEAR - . TRANSMISSION 1ST . & 2ND . SPACER 1 1 BEARING ASSEMBLY A/R CIRCLIP - 2 .42/2 .67 MM A/R CIRCLIP - 1 .75/1 .99 1 GEAR - TRANSMISSION 5 SPEED 1 SPACER 1 SYNCHRONIZER ASS . TRANS . 5 SPEED SPRING - SYNCHRONIZER - CIRCULAR 1 1 INSERT - TRANS . 5 SPEED SYNCHRONIZER 1 RING - TRANS . SYNCHRONIZER BLACKING 1 GEAR - 5 SPEED OUTPUT SHAFT CLUTCH SPACER 1 1 ROLLER BEARING 1 . COUNTERSHAFT CLUSTER GEAR - TRANS 1 COUNTERSHAFT - TRANS . CLUSTER 1 BEARING ASSEMBLY A/R CIRCLIP - 1 .88/2 .26MM 1 GEAR - TRANS . 5 SPEED CLUSTER WASHER - FLAT 1 NUT - SPECIAL 1 1 GEAR - TRANS . REVERSE IDLER 1 SHAFT - REVERSE ISLER GEAR BUSH 1
235 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION F5
DESCRIPTION :GEARBOX - 280I - 5 SPEED. f
COMMENTS :
EUROPEAN
FORD GRANADA - "N" TRANSMISSION GEAR SHIFT COMPONENTS
DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32
PART NO . 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F 025F
481A 482A 483A 484A 485A 486A 487A 488A 489A 490A 491A 492A 493A 494A 495A 496A 497A 498A 499A 500A 501A 502A 503A 504A 505A 506A 507A 508A 509A 510A 511A 512A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
SHAFT ASSEMBLY - GEAR SHIFT 1 PIN 1 PIN ROLL 1 BUSH 1 FORK GEAR SHIFT - 1ST & 2ND SPEED 1 FORK GEAR SHIFT - 3RD & 4TH SPEED 1 1 FORK GEAR SHIFT - 5TH SPEED FORK GEAR SHIFT - REVERSE 1 LEVER - REVERSE GEAR RELAY 1 PIN - RELAY LEVER 1 SPRING - RELAY LEVER RETRACTING 1 CIRCLIP - PIN 1 PLUNGER - FEAR SELECTION LOCK 1 SPRING - GEAR SELECTION PLUNGER 1 PLUG 1 1 ARM & PIN ASSEMBLY ROLL PIN - SELECTOR ARM 1 PLATE ASSEMBLY - INTERIOCK 1 SLEEVE - INTERLOCK 5TH GEAR 1 LEVER - GEAR SHIFT RELEASE 1 BOLT - HEX HEAD 2 SUPPORT ASSEMBLY - CONTROL SELECT LEVER 1 BUSH 1 PIN 1 PLUNGER 1 SPRING 1 1 PLUG 1 SPRING CIRCLIP 1 1 SEAL PLUG 1 1 PIN
236 REMARK
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
F6
DESCRIPTION : GEARBOX - 280I - 3 SPEED AUTOMATIC. r COMMENTS : EUROPEAN FORD GRANADA - TRANSMISSION SELECTOR MECHANISM DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26
PART NO . 027F 027F 027F 027F 027F 027F 027F 027F 027F 027F 027F 027F 027F 027F 027F 027F 027F 027F 027F 027F 027F 027F 027F 027F 027F 027F
047A 044A 045A 046A 048A 043A 042A 038A 060A 039A 040A 041A 055A 056A 058A 059A 049A 054A 053A 065A 064A 063A 066A 062A 051A 052A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION CAP - SELECTOR HANDLE SELECTOR HANDLE SPRING - SELECTOR BUTTON SELECTOR BUTTON SCREW - HANDLE TO LEVER PIN - RETAINING LEVER ASSEMBLY - PAWL ACTUATING CABLE ASSEMBLY BULB SPRING - RETRACTING PAWL LOCKNUT - M4 LOCKNUT - M16 PLUG SEAL SHROUD - DIAL LIGHTING COVER SELECTOR LEVER HOUSING ASSEMBLY BUSH - LOWER SELECTOR LEVER LOWER SELECTOR LEVER END - SELECTOR GEAR CHANGE ROD BUSH - SELECTOR ROD CLIP - SELECTOR ROD RETIANING LOCKNUT - M10 SELECTOR ROD WASHER - ASSEMBLY TO BODY LOCKNUT - M8 - ASSEMBLY TO BODY
i
QUANTITY 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 2 1 1 4 4
47 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION F7
DESCRIPTION : GEARBOX - 2801 - 3 SPEED AUTOMATIC. f
COMMENTS : EUROPEAN FORD GRANADA - C3 TRANSMISSION - COMPONENTS. DATE OF ISSUE - 1/5/86 ITEM
1 2 2A 2B 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44
PART NO .
DATE REVISED
DRAWING REFERENCE
DESCRIPTION
QUANTITY
027F 085A
AUTOMATIC TRANSMISSION
1
027F 513A 027F 514A 027F 515A 027F 516A 027F 517A 027F 518A 027F 519A 027F 520A 027F 521A 027F 522A 027F 523A 027F 524A 027F 525A 027F 526A 027F 527A 027F 528A 027F 529A 027F 530A 027F 531A 027F 532A 027F 533A 027F 534A 027F 535A 027F 536A 027F 537A 027F 538A 027F 539A 027F 540A 027F 541A 027F 542A 027F 543A 027F 544A 027F 545A 027F 546A 027F 547A 027F 548A 027F 549A, 027F 550A 027F 551A 027F 552A 027F 553A 027F 554A 027F 555A 027F 556A 027F 557A 027F 558A
FILTER GASKET - FILTER/VALVE BODY GASKET - BELL HOUSING/TRANS . BODY GASKET - COVER PLATE REAR SERVO ASSEMBLY VALVE BODY COVER PLATE FRONT SERVO ASSEMBLY VACUUM DIAPHRAM THROTTLE SWITCH INHIBITOR SWITCH INTERIOCK & PARKING MECHANISM OIL SEAL - REAR TRANSMISSION PARKING PAWL GOVERNOR ASSEMBLY PISTON RINGS THRUST WASHER NO . 8 GOVENOR HUB & PARKING GEAR CIRCLIP OUTPUT SHAFT FREE WHEEL CLUTCH THRUST WASHER NO . 7 BRAKE BAND BRAKE DRUM REAR PLANET GEAR THRUST WASHER NO . 6 INPUT BELL HOUSING FRONT PLANET GEAR FORWARD CLUTCH THRUST WASHER NO . 3 SUN GEAR REVERSE & TOP GEAR CLUTCH SEALING RING OIL PUMP OIL PUMP GEARS INTERMEDIATE PLATE TORQUE CONVERTER INPUT SHAFT THRUST WASHER NO . 1 SUMP - TRANSMISSION BELLHOUSING - TRANSMISSION BOLT, BELLHOUSING/ENGINE BOLT, REAR EXTENSION/TRANSMISSION REAR EXTENSION GASKET - EXTENSION/TRANSMISSION TRANSMISSION HOUSING
1 1 1 2 1 1 1 1 1 I 1 1 1 1 1 A/R 1 1 1 1 1 1
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 8 6 1 1 1
223 REMARKS
DATE OF ISSUE - 1/5/86 ITEM
N/I N/I N/I N/I N/I N/I
PART NO .
027F 027F 027F 027F 027F 025F
032A 036A 033A 034A 035A 002A
DATE REVISED DESCRIPTION
PROPELLER SHAFT TRANSMISSION OIL SPEEDOMETER DRIVEN GEAR 0 RING - SPEEDOMETER DRIVE RETAINER - SPEEDOMETER DRIVE INSULATOR - TRANS ./CHASSIS
DRAWING REFERENCE QUANTITY
1 1OLTS. 1 1 1 1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
F8
DESCRIPTION : COMMENTS :
GEARBOX - 350I & 390/420 - COMPLETE ASSEMBLY. r ROVER VITESSE 5 SPEED MANUAL.
DATE OF ISSUE - 1/5/86 ITEM
1 1 N/I N/I N/I
PART NO .
035F 035F 035F 025F 035F
086A 086B 067A 026A 069A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION
5 SPEED GEARBOX ASSEMBLY - NEW 5 SPEED GEARBOX ASSEMBLY - REBUILT PROPELLER SHAFT REPAIR KIT - PROPELLOR SHAFR UJ'S GEARBOX MOUNTING RUBBER
QUANTITY
1 1 1 1 2
230 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION F8A
DESCRIPTION : GEARBOX - 350I & 390/420 - GEARCASE, CENTRAL PLATE. A
COMMENTS : ROVER VITESSE 5 SPEED MANUAL. DATE OF ISSUE ITEM i 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17
- 1/5/86
PART U :3jr 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F
DATE REVISED DESCRIPTION
IIUA 111A 112A 113A 114A 115A 116A 117A 118A 119A 120A 121A 122A 123A 124A 125A 126A
DRAWING REFERENCE QUANTITY
GEARCASE ; 'DOWELS/CENTRAL PALTE ASS . PIN, REVERSE LEVER MOUNTING PLAIN WASHER SPRING WASHER NUT - M10 HOLLOW DOWEL, CASE/PLATE HOLLOW DOWEL, CASE/CLUTCH HOUSING CORE PLUG CORE PLUG DRAIN PLUG - MAGNETIC SEALING WASHER BREATHER BODY BREATHER CAP GASKET - GEARCASE/CENTRAL PLATE GASKET - CENTRE PLATE/EXTENSION HOUSING OIL CATCHER OIL FILTER ASSEMBLY
1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1
148 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION F9
DESCRIPTION : GEARBOX - 3501 & 390/420 - EXTENSION CASE. COMMENTS : ROVER VITESSE 5 SPEED MANUAL. DATE OF ISSUE - 1/5/86 ITEM
4 5 6 7 8 9 10 11 12 12 13 14 15 16 17 18 19 20 21 22 22 23 24 25 26 27 28
PART NO .
035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 025W 025W 025W 035F 025W 035F 025W 035F 025W 035F 035F 035F 035F 035F 035F 025W 025W 025W 035F
127A 128A 129A 130A 131A 132A 133A 134A 135A 136A 137A 102A 016A 103A 141A 084A 143A 104A 145A 016A 147A 148A 072A 076A 073A 075A 105A 106A 003A 155A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION
EXTENSION CASE & OIL PUMP ASSEMBLY OIL FEED RING KIT - PUMP GEARS & SHAFT BODY - OIL PUMP SPRING WASHER - BODY/CASE SCREW - M6 X 20 DOWEL INELT PIPE - PUMP O RING - SELECTOR SHAFT OIL FILLER PLUG SEALING WASHER BOLT - M8 X 55 - HOUSING/CASE BOLT - M8 X 50 - HOUSING/CASE SPRING WASHER - M8 MOUNTING BRACKET - HOUSING BOLT - M8 X 30, BRACKET/EXTENSION BUSH - PLASTIC PLAIN WASHER - M8 X 27 X 1 .6MM DISTANCE TUBE BOLT,'M8 X 50 - REMOTE/EXTENSION WASHER - PLASTIC TUBE DRIVE GEAR - SPEEDOMETER - BLACK DRIVE GEAR - SPEEDCOMETER - ORANGE 0 RING - SPEEDOMETER DRIVE GEAR RETAINING PLATE - SPEEDOMETER GEAR SCREW - M6 X 25 SPRING WASHER - M6 PLAIN WASHER - M6 DISTANCE PIECE
QUANTITY
1 1 1 1 3 3 2 1 1 1 1 2 8 10 1 2 4 8 2 2 4 2 1 1 1 1 1 1 1 1
149 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
F10
DESCRIPTION : GEARBOX - 350I & 390/420 - CONSTANT PINION/MAINSHAFT. r COMMENTS : ROVER VITESSE 5 SPEED MANUAL. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6
7 8 9 10 11 12 13 14 15 16 17
PART NO . O' F 035F 025W 025W 035F
156A 157A 107A 006A 160A
035F 035F 035F 035F 035F 035F 03SF 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 03SF 035F 035F 035F 035F 035F 035F 035F 035F
161A 162A 163A 164A 165A 166A 167A 168A 169A 170A 171A 172A 173A 174A 175A 176A 177A 178A 179A 180A 181A 182A 183A 184A 185A 186A 187A 188A 189A 190A 191A 192A 193A
DATE REVISED
DRAWING REFERENCE 150
DESCRIPTION FRONT COVER ASSEMBLY OIL SEAL SCREW - M8 X 25 - COVER/CASE PLAIN WASHER - M8 GASKET SELECTIVE WASHER - CONSTANT PINION 1 .51 MM 1 .57 MM 1 .63 MM 1 .69 MM 1 .75 MM 1 .81 MM 1 .87 MM 1 .93 MM 1 .99 MM 2 .05 MM 2 .11 MM 2 .17 MM 2 .23 MM 2 .29 MM 2 .35 MM 2 .41 MM 2 .47 MM 2 .53 MM 2 .59 MM 2 .65 MM 2 .71 MM 2 .78 MM BEARING, CONSTANT PINION, FRONT CONSTANT PINION - SHAFT ASSEMBLY BEARING, CONSTANT PINION, REAR SPACER, SYNCRO NUB/PILOT BEARING SYNCHROMESH ASSEMBLY - 3RD/4TH . BAULK RING SPRING SHIFTING PLATES 3RD . GEAR NEEDLE BEARING - 3RD . GEAR MAINSHAFT ASSEMBLY
QUANTITY 1 1 6 6 1 1 A/R
1 1 1 1 1 2 2 1 1 1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
F11
DRAWING REFERENCE
151
DESCRIPTION : GEARBOX - 3501 & 390/420 - MAINSHAFT GEARS. COMMENTS :
ROVER VITESSE 5 SPEED MANUAL.
DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10
11 12 13 14 15 16 17 18 19 20 21
22 23 24 25 26 27 28 29
PART NO . 035r 035F 035F 035F 035F 035F 035F 035F 035F
:.94A 195A 196A 197A 198A 199A 200A 201A 202A
035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F
203A 204A 205A 206A 207A 208A 209A 210A 211A 212A 213A 214A 215A 216A 217A
035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 025W 025W
218A 219A 220A 221A 222A 223A 224A 225A 226A 227A 228A 229A 230A, 231A 232A 233A 108A 109A
DATE REVISED DESCRIPTION
2ND . GEAR NEEDLE ROLLER BEARING SYNCHROMESH ASSEMBLY - 1ST/2ND . BAULK RING - 2ND . GEAR SPRING SHIFTING PLATE BAULK RING - 1ST . GEAR 1ST . GEAR NEEDLE ROOLER BEARING - 1ST . GEAR BUSH - 1ST . GEAR 40 .16/40 .21 40 .21/40 .26 40 .26/40 .31 40 .31/40 .36 40 .36/40 .41 BEARING - MAINSHAFT CIRCLIP - BEARING, MAINSHAFT COLLAR - 5TH . GEAR NEEDLE BEARING - 5TH . GEAR 5TH . GEAR SYNCHROMEST ASSEMBLY - 5TH . GEAR BAULK RING - 5TH HUB SPRING SHIFTING PLATE SUPPORT PLATE - 5TH . HUB WASHER - SUPPORT PLATE - 5TH . HUB 5 .10 MM 5 .15 MM 5 .22 MM 5 .28 MM 5 .34 MM 5 .40 MM 5 .46 MM 5 .52 MM 5 .58 MM 5 .64 MM CIRCLIP - 5TH . HUB GEAR - SPEEDOMETER DRIVING ABUTMENT SLEEVE, SPEEDOMETER GEAR BALL BEARING - MAINSHAFT REAR OIL SEAL - EXTENSION CASE - REAR FLANGE PLAIN WASHER - M18 NYLOC NUT - M18
QUANTITY 1 1 1 1 2 3 1 1 1 1 A/R
1 1 1 1 1 1 1 2 3 1 1 A/R
1 1 1 1 1 1 1 1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
F12
DRAWING REFERENCE
152
DESCRIPTION : GEARBOX - 3501 & 390/420 - LAYSHAFT. COMMENTS : ROVER VITESSE 5 SPEED MANUAL. DATE OF ISSUE - 1/5/86 ITEM 1 2 3
4 5 6 7 8 9 10 11 12 13 14
PART NO . 035F 236A 035F 237A 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F
238A 239A 240A 241A 242A 243A 244A 245A 246A 247A 248A 249A 250A 251A 252A 253A 254A 255A 256A 257A 258A 259A 260A 261A 262A 263A 264A
DATE REVISED DESCRIPTION
LAYSHAFT CLUSTER GEAR BEARING - LAYSHAFT SELECTIVE WASHER - LAYSHAFT 1 .69 MM 1 .75 MM 1 .81 MM 1 .87 MM 1 .93 MM 1 .99 MM 2 .05 MM 2 .11 MM 2 .17 MM 2 .23 MM 2 .29 MM 2 .35 MM 2 .41 MM 2 .47 MM 2 .53 MM 2 .59 MM LAYSHAFT GEAR - 5TH . SPEED NUT - LAYSHAFT GEAR -I& BUSH ASSEMBLY SPACER - FRONT SHAFT - REVERSE IDLER ROLL PIN SPACER - REAR LEVER - REVERSE OPERATING PIVOT PIN CIRCLIP - PIN/LEVER SLIPPER PAD - REVERSE GEAR
QUANTITY 1 2 1 A/R
1 1 1 1 1 1 1 1 1 1 1
REMARKS
l
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION F13
DESCRIPTION : GEARBOX - 3501 & 390/420 - SELECTOR LINKAGE. COMMENTS : ROVER VITESSE 5 SPEED MANUAL. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32
PART NO . 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 035F 025W 035F 035F 035F 035F 025W 025W 035F 035F 025W 025W
265A 266A 267A 268A 269A 270A 271A 272A 273A 274A 275A 276A 277A 278A 274A 280A 281A 282A 283A 284A 285A 110A 287A 288A 289A 290A 107A 103A 293A 294A 106A 110A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION SHAFT & FORK ASSEMBLY FORK - 1ST/2ND . GEAR BALL - DETENT SPRING - DETENT BALL PLUG - SPRING RETAINING CIRCLIP - SHAFT REAR SHAFT YOKE - SHAFT/GEAR LEVER SCREW BUSH - NYLON BALL - GEAR LEVER END CIRCLIP - BUSH/YOKE PIN - SELECTOR/SHAFT NYLOC NUT THIN - COUPLING /SHAFT BUSH - NYLON BALL - SHAFT PIN CIRCLIP - SHAFT PIN FORK - 3RD/4TH . GEAR INTERIOCK SPOOL - 1/2/3/4TH . GEAR PLATE ASSEMBLY - INTERLOCK SPRING WASHER SCREW - M16 X 16 MM - PLATE/CASE SELECTOR FORK & BRACKET ASSEMBLY PAD - 5TH . FORK SPIROL PIN CIRCLIP - PIN LOCATING SCREW - M8 X 25 MM - BRACKET/FORK SPRING WASHER - M8 INTERLOCK SPOOL - 5TH . GEAR PLATE ASSEMBLY - INTERLOCK SPRING WASHER - M6 PLATE /CASE SCREW - M6 X 16 MM
QUANTITY 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 2 2 2 2 1 1 2 2
153 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
F14
DRAWING REFERENCE
154
DESCRIPTION : GEARBOX - 3501 & 390/420 - GEARCHANGE HOUSING. COMMENTS : ROVER VITESSE 5 SPEED MANUAL - TVR GEARLEVER. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 N/I N/I N/I N/I N/I N/I N/I
PART NO . 035F 035F 035F 025W 035F 035F 035F 035F 035F 025W 025W 025W 025W 035F 035F 035F 025W 035F 035F 035F 035F 035F 025W 025W 025W 002W 035F 035F 035F 035F 025W 035W 025W 025W 035F 035F 025W 025W 025W
070A 298A 299A 111A 301A 302A 303A 304A 305A 112A 116A 117A 021A 310A 311A 312A 003A 314A 315A 316A 317A 318A 111A 118A 119A 106A 323A 324A 325A 326A 120A 328A 121A 006A 143A 145A O10A 006A 103A
DATE REVISED DESCRIPTION
QUANTITY
GEAR LEVER KNOB LEVER - GEARCHANGE DUST CAP SCREW - M6 X 12 MM, CAP/HOUSING PLUNGER - ANTI RATTLE SPRING - PLUNGER TORSION SPRING - LEVER BIAS RETAINER - SPRING BRACKET - RETAINER SCREW - M6 X 20MM - BRACKET/HSG SCREW - M6 X 20MM - COUNTERSUNK SCREW - M6 X 25MM - TORSION SPRING NUT - PLAIN M8 SWITCH - REVERSE LAMP NUT - SWITCH ADJUST CLIP - HARNESS PLAIN WASHER M6 SLEEVE - CLIP PLATE BACKING PLATE SPACER SPRING SCREW - M6 X 12MM - BAULK ADJUST NUT - PLAIN M6 BOLT - M6 X 40 - PLATE/EXT . HOUSING SPRING WASHER - M6 STEEL SHIM GEARCHANGE HOUSING ASSEMBLY BUSH COVER PLATE/HOUSING SCREW, M5 X 16MM - PLATE/HOUSING SHAKEPROOF WASHER BOLT - M8 X 40 HOUSING/GEARCASE PLAIN WASHER BUSH - PLASTIC DISTANCE PIECE SCREW - M8 X 20 MM, REMOTE HOUSING/BKT PLAIN WASHER - M8 SPRING WASHER - M8
REMARKS
1 1 1 1 1 1 1 2 2 2 2 2 2 1 1 1 1 1 1) 1)REVERSE 2) BAULK 2) 2 2 2 A/R 1 2 1 4 4 2)REPEATED 4) 4) ON 2) 2)GEARCASE 2) 2) PAGE
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION Cl
DESCRIPTION : ROAD WHEEL & TYRE. COMMENTS : 2801 MODELS FROM ` 1980 TO CHASSIS NUMBER 2FH5321FI - FEB . 1982 DATE OF ISSUE - 1/5/86 ITEM
1 2 3 4 5 6 7 8
N/I N/I
N/I N/I
N/I
PART NO .
025G 025G 0250 025G 025G 025G 025G 025G 025G 025T 025T 025T 025T
008A OO1A 002A 004A 003A 007A 005A 006A 009A 002A 003A 005A 017A
DATE REVISED DESCRIPTION
WHEEL & TYRE COMPLETE ALLOY WHEEL DUNLOP TYRE - 206/60 VR 14 WHEEL NUT HUB CENTRE 0 RING WHEEL CENTRE TYRE VALVE BADGE - WHEEL CENTRE STUD - WHEEL JACK & HANDLE WHEELBRACE TOOLBAG SPARE WHEEL COVER - 14"
DRAWING REFERENCE QUANTITY
5 5 20 4 4 5 4 20 1 1 1 1
242 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
G2
DESCRIPTION : ROAD WHEEL & TYRE - MOMO COMMENTS : 280I & 200 MODELS FROM CH .NO . DH5322FI FEB . 1982 - DH5430FI-1/83 DATE OF ISSUE - 1/5/86 ITEM
1 1 2 3 4 5 N/I 6 N/I N/I N/I N/I N/I
PART NO .
025G 025G 025G 025G 025G 025G 020G 025G 025G 025T 025T 025T 025T
013A 014A 015A O10A 016A 005A 023A 004A 009A 002A 003A 005A 017A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION
MOMO ALLOY ROAD WHEEL MOMO ALLOY ROAD WHEEL MOMO CENTRE TVR BADGE GOODYEAR TYRE 205/60 VR WHEEL & TYRE COMPLETE TYRE VALVE GOODYEAR TYRE 195/60 HR WHEEL NUT WHEEL STUD JACK & HANDLE WHEELBRACE TOOLBAG SPARE WHEEL COVER - 14"
QUANTITY
SILVER GOLD 14
14
5 5 4 5 5 5 5 20 20 1 1 1 1
219 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
G3
DRAWING REFERENCE
43
DESCRIPTION : ROAD WHEEL & TYRE - ALL MODELS - 280/350/390 A
COMMENTS : FROM CH . NO . 2FH5431FI JAN . 1983 DATE OF ISSUE - 1/5/86 :EM
i 1 2 2 3 3 3 3 4 4 5 6 7 8 N/I N/I 9 10 N/I
PART NO .
025G 035G 025G 035G 025G 035G 039G 039G 025G 035G 025G 025G 025T 025T 025T 035T 026T 025T 026U
017A 020A 018A 028A O10A 021A 030A 031A 029A 022A 025A 005A 003A 005A 017A 018A O10A 002A 297A
DATE REVISED DESCRIPTION
B .H .S . ALLOY ROAD WHEEL - 14" B .H .S . ALLOY ROAD WHEEL - 15" WHEEL HUB CENTRE - 14" WHEEL HUB CENTRE - 15" GOODYEAR 205/60 VR 14 TYRE GOODYEAR 205/60 VR 15 TYRE YOKOHAMA 215/50 VR 15 TYRE BRIDGESTONE 225/50 VR 16 TYRE WHEEL & TYRE COMPLETE - 14" WHEEL & TYRE COMPLETE - 15" WHEEL NUT - B .H .S . WHEELS TYRE VALVE WHEELBRACE TOOLBAG SPARE WHEEL COVER - 14" SPARE WHEEL COVER - 15" TARGA ROOF PANEL BAG JACK & HANDLE RETAINING HANDLE - SPARE WHEEL
QUANTITY
5 5 4 4 5 5 5 5 5 5 20 5 1 1 1 1 1 1 1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
G4
DESCRIPTION : ROAD WHEEL & TYRE - SPACESAVER - ALL MODELS. COMMENTS : FITTED AS STANDARD FROM JUNE 1985 DATE OF ISSUE - 1/5/86 ITEM
1 2 3 4
~ . ._
035G 035G 026U 025T
;. l
026A 027A 085A 019A
DATE REVISED DESCRIPTION
SPACESAVER TYRE T125/70/D15 ALLOY ROAD WHEEL RETAINING HANDLE - SPACESAVER SPACESAVER WHEEL COVER
DRAWING REFERENCE QUANTITY
1 1 1 1
237 REMARKS _
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION GS
DESCRIPTION : ROAD WHEEL & TYRE - 420 S .E .A .C . MODELS COMMENTS: DATE OF ISSUE - 1/5/86 ITEM
2 3 4 5 6 7 8 9
PART NO .
J42G 042G 042G 042G 025G 025G 025T 025T 025T
032A 033A 034A 035G 025A 005A 003A 002A 005A
DATE REVISED DESCRIPTION
BRIDGESTONE 245/45 VR 15 TYRE MODULAR SPLIT RIM ROAD WHEEL WHEEL CENTRE INSERT WHEEL CENTRE CAP WHEEL NUT TYRE VALVE WHEEL BRACE JACK & HANDLE TOOLBAG
DRAWING REFERENCE QUANTITY
4 4 4 4 20 4 1 1 1
221 REMARK
SECTION
TVR ENGINEERING LIMITED PARTS CATALOGUE .
HI
DESCRIPTION : STEERING - COLUMN & MANUAL RACK - ALL MODELS. r COMMENTS : UP TO CHASSIS NUMBER 2FH5350FI - KAY 1982. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 N/I 7 8 9 10 11 12 13 14 15 16 17 18 19 19 90 21 22 23 24 25 26 27 28 29 N/I N/I N/I N/I N/I
PART NO . 025H OO1B 025H 007A 025H 002A 025H 003A 025H 005A 025H 016A 025H 034A 025H 009A 025W 122A 025H 012A 025H 013A 025H 014A 025H 008A 025H 030A 025H 029A 025H 028A 025H 024A 025H 026A 025H 025A 025H 019A 025H 020A 025H 031A 025H 022A 025H 023A 025H 021A 025H 035A 025W 123A 025W 013A 025W 011A 025H 036A 025H 037A 025H 038A 025H 039A 025H 040A 025U 036A 025U 041A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
STEERING WHEEL STEERING COLUMN STEERING WHEEL CENTRE STEERING WHEEL NUT WASHER - PLAIN LOCK - STEERING COLUMN KEY - IGNITION BOLT - SHEAR - LOCK TO STEERING COLUMN BOLT - M10 X 40 - COLUMN/MOUNTING BKT . NACELLE - UPPER NACELLE - LOWER SCREW - NACELLE BUSH - LOWER COLUMN C/W FIXING PLATE UNIVERSAL JOINT UPPER - TORRINGTON SHAFT - INTERMEDIATE STEERING UNIVERSAL JOINT LOWER - TORRINGTON TRACK ROD END NUT - TRACK ROD END NUT - LOCK - TRACK ROD END STEERING RACK MANUAL - R .H .D . STEERING RACK MANUAL - L .H .D . CLAMP - SMALL - RACK MOUNTING INSULATOR - SMALL - RACK MOUNTING CLAMP - LARGE - RACK MOUNTING INSULATOR - LARGE - RACK MOUNTING BALL PIN REPAIR KIT BOLT - M10 X 35 - RACK MOUNTING PLAIN WASHER - M10 NUT - NYLOC - M10 GAITER - RUBBER - LARGE GAITER - RUBBER - SMALL CLIP - GAITER, LARGE CLIP - GAITER,MEDIUM CLIP - GAITER, SMALL STEERING COLUMN BRACKET - R .H .D . STEERING COLUMN BRACKET - L .H .D .
1 1 1 1 1 1 2 2 2 1 1 2 1 1 1 1 2 2 2 1 1 1 1 1 1 2 4 8 4 1 1 1 1 1 1 1
243 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
H2
DRAWING REFERENCE
3
DESCRIPTION : STEERING - COLUMN & MANUAL RACK - ALL MODELS. r. COMMENTS : FROM CH . NO . DH5351FI JUNE 1982 TO DH6015RI. DATE OF ISSUE - 1/5/86 ITEM
PART NO .
1 2 3 4 N/I 4A N/I 5 6 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 24 25 26 27 28
025H 025H 025H 025H 025H 025H 025H 025H 125U 025U 025W 025W 025W 025H 025H 025H 025H 025H 025W 025W 025H 025H 025W 025H 025H 025H 025H 025H 025H 025H 025H 025H 025H
149A 003A 005A 085A 047A 086A 048A 012A 041A 036A 013A O11A 124A 007A 026A 024A 023A 021A 123A 013A 031A 022A O11A 035A 040A 037A 039A 019A 020A 038A 036A 025A 043A
29 30 31 32 33 33 34 35 36
025H 025H 025H 025W 125H 025H 025H 025H 025H
044A 008A 018A 122A 017A 016A 009A 014A 013A
N/I
025H 034A
DATE REVISED DESCRIPTION
QUANTITY
STEERING WHEEL CENTRE - MOMO STEERING WHEEL NUT WASHER - PLAIN STEERING WHEEL - MOMO STEERING WHEEL - MOUNTNAY HUB KIT - MOMO STEERING WHEEL HUB KIT - MOUNTNAY STEERING WHEEL NACELLE - UPPER BRACKET ASSEMBLY - COLUMN MTG . - L .H .D . BRACKET ASSEMBLY - COLUMN MTG . - R .H .D . PLAIN WASHER - M10 NUT - NYLOC - M10 BOLT - M10 X 25 - BODY TO COLUMN BKT . STEERING COLUMN NUT - TRACK ROD END TRACK ROD END CLAMP - LARGE - RACK MOUNTING INSULATOR - LARGE - RACK MOUNTING BOLT - M10 X 35 - RACK MOUNTING PLAIN WASHER - M10 CLAMP - SMALL - RACK MOUNTING INSULATOR - SMALL - RACK MOUNTING NUT - NYLOC - M10 BALD. PIN REPAIR KIT CLIP - GAITER, SMALL GAITER - RUBBER - SMALL CLIP - GAITER, MEDIUM STEERING RACK - MANUAL - R .H .D . STEERING RACK - MANUAL - L .H .D . CLIP - GAITER - LARGE GAITER - RUBBER - LARGE NUT - LOCK - TRACK ROD END LOWER STEERING COLUMN JOINT - NARDELA ( COMBINED WITH INTERMEDIATE SHAFT ) UPPER STEERING COLUMN JOINT - NARDELA BUSH - LOWER COLUMN C/W FIXING PLATE SPACER - COLUMN MOUNTING BOLT - M10 X 40 - COLUMN TO BRACKET LOCK - STEERING COLUMN - U .S .A . LOCK - STEERING COLUMN - U .K . BOLT - SHEAR - LOCK TO COLUMN SCREW - NACELLE NACF1 .YF - LOWER
1 1 1 1 1 1 1 1 1 1 10 5 3 1 2 2 1 1 4 8 1 1 4 2 2 1 1 1 1 1 1 2 1
KEY - IGNITION
2
1 1 A/R 2 1 1 2 2 1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
H3
DESCRIPTION : STEERING - ADJUSTABLE COLUMN. COMMENTS : ALL MODELS FROM CHASSIS NUMBER DH6016RI - MARCH 1985 DATE OF ISSUE - 1/5/86 ITEM 1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 17 18 19 20 20 21 21 22 23 24 25 26 27 28 29 30
PART NO . 125U 025U 025W 025W 025W 025W 025H 025H 025H 025H 025H 025H 025H 025W 025W 025W 025W 025H 025H 025H 025W 025H 025H 025H 025H 025H 025H 025H 025H 025H 125H 025M 025W 025W
349A 350A 124A 013A 011A 125A 145A 146A 147A 148A 101A 108A 109A 015A 036A 003A 002A 149A 150A 111A 126A 112A 130A 107A 129A 104A 103A 277A 106A 151A 102A 446A 444A 445A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
MOUNTING BRACKET - COLUMN/BODY - L .H . MOUNTING BRACKET - COLUMN/BODY - R .H . BOLT - M10 X 25 - BODY TO BRACKET PLAIN WASHER - M10 - BRACKET MOUNTING NUT - MYLOC - M10 SETSCREW - BRACKET/COLUMN TO BKT/BODY BRACKET - COLUMN MOUNTING KNOB - CLAMPING COLUMN SPRING - BOLUMN CLAMPING DOWEL - KNOB LOCATING COLUMN BUSH - LOWER COLUMN MOUNTING BRACKET - BUSH M6 X 20 SETSCREW - BRACKET RETAINING 25 MM LARGE WASHER M6 PLAIN WASHER NUT - M6 NYLOC STEERING WHEEL CENTRE - MOMO STEERING WHEEL CENTRE - PERSONEL STEERING WHEEL NUT WASHER - PLAIN M14 STEERING WHEEL - MOMO STEERING WHEEL - PERSONEL HUB - STEERING WHEEL - MOMO HUB - STEERING WHEEL - PERSONEL LOWER NACELLE UPPER NACELLE SWITCH - DIMMER - INSTRUMENTS SCREW - NACELLE - 3/4" BOLT - SHEAR - STEERING LACK STEERING COLUMN LACK SWITCH - SIDE & HEADLAMPS SWITCH - HORN, H .LIGHT FLASH,INDICATORS SWITCH - SCREEN WASH & WIPE
1 1 3 10 5 2 1 1 1 1 1 1 1 2 2 2 2 1 1 1 1 1 1 1 1 1 1 2 2 1 1 1 1
85 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
H4
DESCRIPTION : STEERING - MANUAL RACK - ALL MODELS - COMPONENTS. 1
COMMENTS : CAM GEARS RACK - L .H .D . & R .H .D. DATE OF ISSUE - 1/5/86 ITEM 1 1 2 3 4 5 6 7 8 9 10 10A 11 11A 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37
PART NO . 025H 025H 025H 025H 025H 025H 025H 025H 025W 025W 025H 024H 025H 025H 025H 025H 025H 025H 025H 025H 625H 025W 025H 025H 025H 025H 025H 025H 025H 025H 025H 025H 025H 025H 025H 025H 025W 025W 025H 025H
019A 020A 152A 153A 154A 155A 156A 157A 123A 013A 023A 031A 021A 022A 158A 159A 160A 161A 162A 163A 164A 011A 165A 166A 167A 168A 169A 035A 026A 024A 025A 040A 036A 038A 039A 037A 009A 005A 043A 028A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
210 REMARKS
STEERING RACK - R .H .D . - COMPLETE 1 STEERING RACK - L .H .D . - COMPLETE 1 SETSCREW - COVERPLATE RETAINING 4 1 COVER PLATE - RACK SLIPPER BEARING GASKET - COVER PLATE 1 SHIM - RACK SLIPPER BEARING A/R SPRING - RETAINING 1 BEARING - RACK SLIPPER 1 4 BOLT - M10 X 35 - RACK MOUNTING PLAIN WASHER - M10 8 CLAMP - LARGE - RACK MOUNTING 1 CLAMP - SMALL - RACK MOUNTING 1 INSULATOR - LARGE - RACK MOUNTING 1 INSULATOR - SMALL - RACK MOUNTING 1 PINION SEAL 1 COVER PLATE - PINION BEARING 1 GASKET - COVER PLATE 1 SHIM - PINION BEARING A/R BEARING - PINION UPPER 1 PINION . 1 BEARING - PINION LOWER 1 4 NUT - NYLOC - M1O 2 SPRING SEAL - BALL JOINT 2 2 LACKING RING LACKING PIN 2 HOUSING - BALL JOINT 2 2 REPAIR KIT - BALL PIN NUT - TRACK ROD END 2 2 TRACK ROD END 2 LOCKNUT 2 CLIP - GAITER - SMALL . GAITER - RUBBER - LARGE 1 1 CLIP - GAITER - LARGE 1 CLIP - GAITER - MEDIUM GAITER - RUBBER - SMALL 1 BOLT - M8 X 35 - UJ CLAMPING 3 3 NUT - NYLOC - M8 LOWER SHAFT C/W UNIVERSAL JOINT 1 UNIVERSAL JOINT - UPPER - TO SD1 COLUMN 1
it
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
H5
DESCRIPTION :STEERING - POWER ASSISTED - CAM GEARS RACK. e COMMENTS : L .H .D . TO DATE . R .H .D . TO SA9DH35PXFB019414. DATE OF ISSUE - 1/5/86 ITEM 1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 25 25 26 27 28 29 30
PART NO . 028H 028H 025W 025W 028H 028H 025W 025W 028H 028H 028H 028H 028H 028H 028H 028H 028H 028H 028H 028H 025H 025H 025H 028H 028H 028H 025H 025H 028H 025H 025W 025W 028H
053A 054A 054A 013A 075A 076A O11A 127A 172A 173A 174A 175A 176A 177A 178A 179A 180A 181A 182A 183A 025A 024A 026A 184A 185A 055A 028A 030A 056A 115A 009A 005A 186A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
RACK - POWER STEERING - R .H .D . 1 RACK - POWER STEERING - L .H .D . 1 BOLT - M10 X 30 - RACK RETAINING 2 WASHER - PLAIN - M10 8 CLAMP - RACK TO CHASSIS 1 INSULATOR 1 NUT - NYLOC - M10 4 BOLT - M10 X 45 - RACK TO CHASSIS 2 RAM FEED PIPE - TOP OF PINION TO L .H . 1 RAM FEED PIPE - TRACK ROD END TO END 1 RAM FEED PIPE - BOTTOM OF PINION/R .H . 1 0 RING 1 SPRING 1 SHIM A/R GASKET 1 COVER PLATE 1 BOLT - RETAINING 2 CLIP - GAITER - LARGE 2 GAITER - RUBBER 2 CLIP - GAITER - SMALL 2 LOCKNUT 2 TRACK ROD END 2 LOCKING NUT 2 TRACK ROD REPAIR KIT 2 SEAL KIT - PINION 1 LOWER JOINT - NON ADJUSTABLE COLUMN R .H .1 LOWER JOINT - ADJUSTABLE COLUMN - L .H .D .1 LOWER JOINT - ADJUSTABLE COLUMN - R .H .D .1 INTERMEDIATE SHAFT - ALL L .H .D . 1 UPPER JOINT - ALL L .H .D . 1 2 BOLT - M8 X 35 - U .J . CLAMPING NUT - NYLOC - M8 2 INTERMEDIATE SHAFT C/W U .J . - ALL R .H .D .1
211 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
H6
DESCRIPTION : STEERING - POWER ASSISTED - SUPRA/TVR RACK. COMMENTS :R .H .D . U .K . MARKET ONLY - FROM VIN SA9D135P5FB019415 - JULY 1985 DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23
PART NO . 038H 038H 038H 038H 038H 038H 038H 038H 038H 038H 038H 038H 038H 025H 025H 025H 025W 025W 025W 025H 025W 025W 028H
114A 187A 188A 189A 190A 191A 192A 193A 194A 195A 196A 197A 198A 025A 026A 024A 011A 013A 122A 030A 009A 005A 186A
DATE REVISED
DRAWING REFERENCE 214
DESCRIPTION RACK - POWER STEERING - R .H .D . RAM FEED PIPE - TO BOX END PIPE - AIR TRANSFER RAM FEED PIPE - TO BRACKET END PINION ASSEMBLY PINION HOUSING KIT SHIM KIT - TOP PINION OIL SEAL KIT - RACK SHIM KIT - ADJUSTER BUTTON OIL SEAL KIT - PINION PINION RACE KIT BELLOWS - KIT WITH CLIPS TRACK ROD REPAIR KIT LOCKNUT LOCKING NUT TRACK ROD END NUT - NYLOC - M10 PLAIN WASHER - M10 BOLT - M10 X 40 - RACK RETAINING LOWER UNIVERSAL JOINT BOLT - M8 X 35 - U .J . CLAMPING NUT - NYLOC - M8 INTERMEDIATE SHAFT C/W U .J .
QUANTITY 1 1 1 1 1 1 1 1 1 1 1 1 1 2 2 2 4 8 4 1 2 4 1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
H7
DESCRIPTION : STEERING - POWER ASSISTED - PUMP & MOUNTING BRACKET. COMMENTS : ALL VEE 6 MODELS WITH AIR CONDITIONING. DATE OF ISSUE - 1/5/86 ITEM!
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34
PART NO . 125H 025W 025W 025W 025W 125H 025W 125H 125H 125H 125H 025W 025W 025W 125H 125H 025W 125H 025W 025W 025W 025P 035P 125H 025W 025W 025W 029P 028H 125H 025W 025W 025W 025W
141A 002A 003A 105A 046A 140A 059A 144A 199A 143A 134A 129A 050A 013A 171A 135A 122A 137A 003A 106A 105A 074A 085A 133A 128A 131A 053A 073A 077A 170A 018A O10A 103A 130A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
BRACKET - REMOTE RESERVOIR NUT - NYLOC - M6 M6 PLAIN WASHER SETSCREW - M6 X 25 - RESERVOIR MOUNTING SELFTAP 8 X 3/4" - BRACKET TO BODY RESERVOIR - REMOTE - POWER STEERING JUBILEE CLIP - P .A .S . HOSE HOSE - OIL RETURN FROM RACK HOSE - RESERVOIR TO PUMP FEED PIPE - OIL FEED TO RACK PUMP - POWER STEERING BOLT - M10 X 100 - BRACKET MOUNTING SPRING WASHER - M10 PLAIN WASHER - M1O KEY - LOCATING BRACKET - PUMP MOUNTING BOLT - M10 X 40 - STIFFENER BKT . MTG . BRACKET - PUMP STIFFENER PLAIN WASHER - M6 SPRING WASHER - M6 SETSCREW - M6 X 25 - BRACKET TO PUMP SHOULDER BOLT TO PULLEY JOCKEY PULLEY HUB - PUMP PULLEY SETSCREW - M12 X 35 - ECCENTRIC/BLOCK SPRING WASHER - M12 PLAIN WASHER - M12 ECCENTRIC PULLEY - P .A .S . PUMP BELT - P .A .S . NUT - NYLOC - M12 SETSCREW - M8 X 20 - PULLEY TO HUB SPRING WASHER - M8 BOLT - 3/8" X 1 1/2" UNF
1 2 4 2 4 1 3 1 1 1 1 2 3 3 1 1 1 1 4 4 4 1 1 1 1 1 1 1 1 1 1 3 1
213 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
H8
DESCRIPTION : STEERING - POWER ASSISTED - PUMP & MOUNTING BRACKET. r COMMENTS : ALL R .H .D . VEE 8 MODELS - PUMP LOCATED LOWER R .H . SIDE OF BLOCK. DATE OF ISSUE - 1/5/86 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 19 20 20
PART 0250 025W 025W 038H 038H 025W 025W 025W 038H 025W 025W 025W 038H 025W '025W 025W 038H 025W 038H 038H 038H 038H
e. O10A 103A 006A 113A 083A 132A 098A 097A 081A 134A 135A 133A 082A 105A 106A 003A 080A 059A 093A 123A 092A 122A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
SETSCREW - M8 X 20 - PULLEY TO PUMP SPRING WASHER - M8 PLAIN WASHER - M8 BELT - P .A .S . PULLEY - P .A .S . BOLT - 3/8" X 1 1/4" UNF - RKT . RET . SPRING WASHER - 3/8" PLAIN WASHER - 3/8" MOUNTING BRACKET - PUMP PLAIN WASHER - 5/16" SPRING WASHER - 5/16" SETSCREW - 5/16" X 1" UNC - BKT/BLOCK MOUNTING PLATE - PUMP SETSCREW - M6 X 25 - BRACKET/PUMP SPRING WASHER - M6 PLAIN WASHER - M6 PUMP - POWER STEERING CLIP - PIPE TO PUMP HOSE - OIL RETURN FROM CAM GEARS RACK HOSE - OIL RETURN FROM SUPRA/TVR RACK PIPE_- FEED LINE TO CAM GEARS RACK PIPE - FEED LINE TO SUPRA/TVR RACK
3 3 3 1 1 3 3 3 1 1 1 1 1 3 4 4 1 1 1 1 1 1
238 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION H9
DESCRIPTION : STEERING - POWER ASSISTED - PUMP & MOUNTING BRACKET. COMMENTS : ALL L .H .D . VEE 8 MODELS - PUMP LOCATED HIGH R .H . SIDE OF BLOCK. /5/86
DATE OF IS, I 1' EM i 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26
PART _
038H 025W 025W 025W 038H 025W 025W 025W 025W 025W 025W 038H 025W 038H 038H 025W 038H 025W 038H 025W 025W 025W 025W 025W 038H 038H
i. t
113A 101A 103A 006A 083A 136A 050A 013A 037A 106A 003A 117A 137A 118A 117A 002A 080A 059A 093A 138A 098A 097A 139A 134A 092A 119A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
BELT - P .A .S . SETSCREW - M8 X 20 - PULLEY TO PUMP SPRING WASHER - M8 PLAIN WASHER - M8 PULLEY - P .A .S . BOLT - M10 X 90 - SPACER/BRACKET/BLOCK SPRING WASHER - M10 PLAIN WASHER SETSCREW - M6 X 30 - SPACER/PUMP SPRING WASHER - M6 PLAIN WASHER - M6 SPACER - OIL PUMP SETSCREW - M6 R 35 GUSSET SPACER NUT - NYLOC - M6 PUMP - P .A .S . JUBILEE CLIP - RETURN HOSE HOSE - RETURN FROM RACK SETSCREW - 3/8" X 1" UNC - EXT . MT . SPRING WASHER - 3/8" PLAIN WASHER - 3/8" BOLT - 5/16" X 4 1/2" - EXT . MT . PLAIN WASHER - 5/16" PIPE - FEED TO RACK BRACKET - P .A .S . PUMP
1 3 3 3 1 1 1 1 4 4 6 1 1 1 1 1 1 1 1 4 4 4 1 1 1 1
208 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
J1
DESCRIPTION : BRAKES - HANDBRAKE ASSEMBLY. COMMENTS : VERTICAL TYPE - 1980 TILL CHASSIS NUMBER FHSO97FI - AUGUST 1980 DATE OF ISSUE - 1/5/86 ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
11
-
12 13 14
025W 005A 025J 061A 025W 021A
1 HANDBRAKE LEVER ASSEMBLY 2 BOLT - M1O X 30 12 PLAIN WASHER - K1O 2 NUT - NYLOC - M1O PIN - CLIVIS 1 1 CLIP - CLIVIS PIN 6 PLAIN WASHER - M8 1 CABLE - HANDBRAKE P CLIP - HANDBRAKE CABLE - INCLUDING 11 1 1 BOLT - M8 X 25 1 BUSH - RUBBER - INCLUDED IN ITEM 9 1 NUT - NYLOC - M8 PROTECTIVE COVER FOR HANDBRAKE CABLE 1 2 NUT - ADJUSTING - M8 PLAIN
N/I
025J 034A
PADS - HANDBRAKE
1 2 3 4 5 6 7 8 9 10
025J 025W 025W 025W 025J 025J 025W 025J 025J 025W
032A 054A 013A O11A 031A 051A 006A 030A 044A 055A
1 SET .
257 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
J2
DESCRIPTION : BRAKES - HANDBRAKE ASSEMBLY. COMMENTS : ALL MODELS FROM CHASSIS NUMBER ;- FHSO98F1 - AUGUST 1980 DATE OF ISSUE - 1/5/86 ITEM
PART NO .
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
025J 025W 025J 025W 025W 025W 025J 025J 025J 025J 025W 025W 025J 025W 025W 025J 025J 025M 025W
N/I
025J 034A
061A 021A 030A 005A 006A 037A 099A 097A 098A 065A 013A 032A 067A 002A 003A 101A 068B 271A 051A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION
QUANTITY
PROTECTIVE COVER FOR HANDBRAKE CABLE NUT - ADJUSTING - M8 PLAIN CABLE - HANDBRAKE NUT - NYLOC - M8 PLAIN WASHER - M8 SETSCREW - M6 K 30 BOLT - PIVOT - HANDBRAKE PIN - CLIVIS CLIP - CLIVIS PIN HANDBRAKE LEVER ASSEMBLY PLAIN WASHER - M10 NUT - NYLOC - HANDBRAKE PIVOT HANDBRAKE SPREADER MOUNTING PLATE NUT - NYLOC - M6 PLAIN WASHER - M6 MOUNTING BRACKET - HANDBRAKE LEVER MOUNTING PLATE - HANDBRAKE ABUTMENT SWITCH - WARNING LIGHT - HANDBRAKE NUT - ADJUSTMENT - SWITCH
1 2 1 5 5 1 1 1 1 1 1 1 1 1 1 1 1 1 1
PADS - HANDBRAKE
1 SET
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION J3
DESCRIPTION : BRAKES - HYDRAULIC SYSTEMS - GENERAL LAYOUT COMMENTS : L .H .D . SYSTEM - LOCKHEAD SERVOMASTER CYLINDER TILL JUNE 198 DATE OF ISSUE ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37
PART NO . 025J 025J 125J 025J 125J 125J 125J 025J 025J 025U 025U 025J 025J 025J 025J 025J 025J 025J 025J 025J 025J 125J 025J 025W 025W 025W 025J 025J 025J 025J 025J 025J 125J 025J 125J 025J 025J
006A O10A 096A 091A 095A ''53A :;A 019A 020A 336A 158A 026A 055A 036A 035A 062A 025A 022A 060A 021A 024A 094A 064A 140A 013A 013A O11A 012A 100A 007A 001A 003A 092A 077A 093A 013A 004A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
CALIPER - FRONT - R .H . HOSE - RUBBER - FRONT BRAKE PIPE - G VALVE TO REAR FLEXIBLE HOSE G VALVE PIPE - MASTER CYLINDER TO G VALVE MASTER CYLINDER - LOCKHEAD SERVO ASSEMBLY - LOCKHEAD CLEVIS - BRAKE PEDAL CLEVIS PIN PEDAL - BRAKE RUBBER - BRAKE PEDAL HOSE - RUBBER - REAR BRACKET - REAR BRAKE HOSE WASHER - REAR BRAKE HOSE NUT - PLAIN - REAR BRAKE HOSE PIPE - BRACKET TO REAR CALIPER REAR CROSS PIPE CALIPER - REAR R .H . LINK PIPE - REAR CALIPERS CALIPER - REAR L .H . DISC - REAR PIPE - MASTER CYLINDER TO 3 WAY UNION BRACKET - G VALVE MOUNTING BOLT - M10 X 75 - G VALVE MOUNTING PLAIN WASHER - M1O NUT - NYLOC - M1O WASHER - FRONT BRAKE HOSE NUT - FRONT BRAKE HOSE PIPE - HOSE TO CALIPER - L .H . CALIPER - FRONT - L .H . DISC - FRONT SPLASH SHIELD - L .H . PIPE - 3 WAY UNION TO HOSE - L .H . 3 WAY UNION PIPE - 3 WAY UNION TO HOSE - R .H . PIPE - HOSE TO CALIPER - R .H . SPLASH SHIELD - R .H .
1 1 1 1 1 1 1 1 1 1 1 1 1 2 2
1 1 1 1 1 2 1 1 1 2 1 4 4 1 1 2 1 1 1 1 1 1
REMARK
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
DESCRIPTION : BRAKES - SERVO, MASTER CYLINDER & PIPES -
J4
R .H .D.
COMMENTS : GIRLING 74049211 - T38 SUPERVAC + 13/16" MASTER CYLINDER. DATE OF ISSUE - 1/5/86 ITEM
PART NO .
1 2 3 4 5 6 7 8 9 10 11
025U 025J 025J 025J 025J 025J 025J 025J 025J 025J 025J
336A 017A 082A 029A 056A 015A 100A 091A 011A 012A 010A
N/I
025J 103A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
. BRAKE PEDAL - R .H .D . SERVO ASSEMBLY MASTER ASSEMBLY PIPE - MASTER CYLINDER REAR TO G VALVE PIPE - G VALVE TO REAR FLEXIBLE HOSE PIPE - MASTER CYL .FRONT TOP TO RH HOSEE PIPE - MTR . CYL . FRONT BOTTOM/ LII HOSE G VALVE NUT - RETAINING - FLEXIBLE HOSE PLAIN WASHER - FLEXIBLE HOSE HOSE - FLEXIBLE - FRONT RH & IA
1 1 1 1 1 1 1 1 2 2 2
BRAKE PIPE SET - R .H .D .
1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
J5
DESCRIPTION : BRAKES - SERVO, MASTER CYLINDER & PIPES - L .H .D. COMMENTS : GIRLING 74049211 - T38 SUPERVAC + 13/16" MASTER CYLINDER. DATE OF ISSUE - 1/5/86 ITEM
PART NO .
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16
025U 025J 025J 125J 125J 025J 125J 025J 025W 025W 025W 125J 025J 025J 125J 025J
336A 017A 082A 095A 096A 091A 094A 077A 037A 003A 002A 093A 012A 011A 092A O10A
N/I
125J 102A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
BRAKE PEDAL SERVO ASSEMBLY MASTER CYLINDER PIPE - MASTER CYLINDER TO G VALVE PIPE - G VALVE TO REAR FLEXIBLE HOSE G VALVE PIPE - MASTER CYLINDER FRONT TO T PIECE T PIECE BOLT - M6 X 30 ( WELDED TO CHASSIS ) PLAIN WASHER - K6 NUT - NYLOC PIPE - T PIECE TO L .H . HOSE PLAIN WASHER - FLEXIBLE HOSE NUT - HOSE RETIANING PIPE - T PIECE TO R .H . HOSE HOSE - FLEXIBLE - FRONT RH & LH
1 1 1 1 1 1 1 1 1 1 1 1 2 2 1 2
BRAKE PIPE SET - L .H .D .
1
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
J6
DESCRIPTION : BRAKES - FRONT CALIPERS, DISC & G VALVE - ALL MODELS r COMMENTS: DATE OF ISSUE ITEM
1 1 2 2 3 3 4 4 5 5 6 7 8 9 10 10 10 10 11 12 13 14 15 16 17 18 19 20
- 1/5/86
PART NO .
025J 039J 025J 039J 025J 039J 025J 039J 025J 039J 025J 025J 025J 025J 025J 025J 039J 039J 025J 025J 025J 039J 025J 025J 025W 025W 025W 025W
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
111A PISTON SET - 280/350 CALIPER 112J PISTON SET - 390/420 CALIPER SEAL KIT - PISTONS - 280/350 113A 114A SEAL KIT - PISTONS - 390/420 115A RETAINING RING - 280/350 PISTONS 116A RETAINING RING - 390/420 PISTONS 117A PAD RET . SPG & SHIMS - 280/350 110A PAD RET . SPG & SHIM - 390/420 018A PADS SET - 280/350 CALIPER 109A PADS SET - 390/420 CALIPER 118A SPLIT PIN - PAD RETAINING BOLT 119A CLEVIS PIN - PAD RETIANING 120A DUST COVER - BLEED NIPPLE 084A BLEED NIPPLE - FRONT CALIPER 006A CALIPER ASSEMBLY LESS PADS - R .H . 350 007A CALIPER ASSEMBLY LESS PADS - L .H . 350 108A CALIPER ASSEMBLY LESS PADS - R .H . 390 107A CALIPER ASSEMBLY LESS PADS - L .H . 390 DISC BRAKE - SOLID - 280/350 OO1A 009A LOCKING PLATE 002A BOLT - HUB/DISC - M12 X 33 106A DISC BRAKE - VENTILATED - 390/420 064A BRACKET - G VALVE MOUNTING 091A G VALVE BOLT - G VALVE MOUNTING - M10 X 75 140A 045A SELF TAP - BRACKET TO BODY 013A PLAIN WASHER - M10 013A NUT - NYLOC - M1-
2 2 2 2 4 4 2 2 2 2 2 4 4 2 1 1 1 1 2 2 4 2 1 1 1 4 1 1
247 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
J7
DESCRIPTION : BRAKES - REAR CALIPER, HANDBRAKE CALIPER & DISC. r. COMMENTS : AS PER JAGUAR XJS DATE OF ISSUE - 1/5/86 ITEM 1 2 3 3 4 5 6 7 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 28 29 29 29 30
PART NO . 025J 025J 025J 025J 025J 025J 025J 025J 025J 025J 025J 025J 025J 025J 025J 025J 025J 025J 025J 025J 025J 025J 025J 025J 025J 025J 025J 025W 025J 025J 025J 025J 025J 025J 025J
121A 122A 123A 124A 125A 126A 127A 128A 129A 130A 131A 132A 133A 134A 135A 136A 137A 138A 034A 139A 140A 141A 142A 083A 143A 144A 033A 040A 023A 022A 021A 037A 038A 039A 024A
DATE REVISED
DRAWING REFERENCE
DESCRIPTION BOLT - PAD CARRIER TO LEVER SPLIT PIN HANDBRAKE CALIPER ASSEMBLY - R .H . HANDBRAKE CALIPER ASSEMBLY - L .H . ANCHOR PIN FOR RETURN SPRING PROTECTION COVER - FRONT RETURN SPRING OPERATING LEVER ASSEMBLY - R .H . OPERATING LEVER ASSEMBLY - L .H . FRICTION SPRING ADJUSTING NUT SPRING WASHER BOLT - SECURING COVER PAWL ASSEMBLY TENSION SPRING FOR PAWL SPLIT PIN - RETAINING HINGE PIN HINGE PIN FOR OPERATING LEVER ANCHOR PIN FOR TENSION SPRING PADS - HANDBRAKE MECHANISM BOLT - HANDBRAKE TO CALIPER TAB WASHER RETRACTION PLATE CALIPER SEAL . KIT BLEED NIPPLE - REAR CALIPER PISTON SET BRIDGE PIPE PAD SET - REAR CALIPER SPRING WASHER BOLT - REAR CALIPER MOUNTING CALIPER ASSEMBLY - R .H . CALIPER ASSEMBLY - L .H . SHIM - 0 .020" SHIM - 0 .010" SHIM - 0 .005" DISC - DAMPER
QUANTITY 2 2 1 1 2 2 2 1 1 2 2 2 2 2 2 2 2 2 4 4 2 2 2 2 2 2 2 4 4 1 1 A/R A/R A/R 2
10 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION : BRAKES - PEDAL
OX
- ALL MODELS
SECTION
J8
- HYDRAULIC CLUTCH
COMMENTS : MANUAL TRANSMISSION - L .H .D . & R .H .D . TVR NOT TRIUMPH TYPE DATE OF ISSUE - 1/5/86 ITEM
PART NO .
1 2 3 4 5 6 6 7 8 9 10 11 11
035U 025U 025U 025U 025J 125Q 025J 025W 025U 025U 025W 035U 025U
344A 334A 335A 130A 020A 053A 019A 021A 336A 416A 013A 339A 338A
12 13 14 15 16 17 18 19 20 21 22 23 23 23 23
025W 025W 025W 025W 025W 025M 025W 025W 025U 025J 025J 035E 035E 025E 125E
118A 117A 006A 005A 018A 019A 064A 009A 333A 054A 145A 095A 644A 002A 155A
24 25 26 27 28 29 30 30 30 31
025J 025J 025W 025W 025J 025W 035Q 042Q 125Q 025U
017A 082A 013A 051A 146A 141A 038A 063A 054A 332A
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
PEDAL RETURN SPRING 2 BUSH - PEDAL PIVOT 4 CLUTCH PEDAL 1 PEDAL RUBBER - TVR LOGO 3 RETAINER - CLEVIS PIN 1 CLEVIS PIN - VEE 8 MODELS 2 CLEVIS PIN - VEE 6 MODELS 2 M8 PLAIN LOCKNUT 1 BRAKE PEDAL 1 SPLIT PIN 1 M10 PLAIN WASHER 1 ACCELERATOR PEDAL ASSEMBLY - VEE 8 1 ACCELERATOR PEDAL ASSEMBLY - VEE 6 1 ( VEE 6 ITEM ILLUSTRATED ) M6 PLAIN LOCKNUT - THROTTLE STOP .1 M6 X 25 SCREW - THROTTLE STOP 1 M8 PLAIN WASHER - SERVO MOUNTING 6 M8 NYLOC NUT - SERVO MOUNTING 6 M12 NYLOC NUT - BRAKE LIGHT SWITCH MTG . 1 SWITCH - BRAKE LIGHT WARNING 1 PLAIN WASHER - BODY/BOX MOUNTING 2 M8 X 35 BOLT - BOX MOUNTING 2 PIVOT PIN - CLUTCH/BRAKE PEDALS 1 HOSE - SERVO VACUUM A/R KIT - SERVO NON RETURN VALVE 1 ACCELERATOR CABLE - VEE 8 1 ACCELERATOR CABLE - VEE 8 METAL TYPE 1 ACCELERATOR CABLE - VEE 6 R .H .D . 1 ACCELERATOR CABLE - VEE 6 L .H .D. 1 ( VEE 6 ITEM ILLUSTRATED ) SERVO ASSEMBLY - GIRLING 1 MASTER CYLINDER - BRAKES - GIRLING 1 M10 PLAIN WASHER 2 2 M1O PLAIN NUT - SERVO/MASTER CYLINDER KIT - SERVICE - SERVO 1 M8 X 30 BOLT - CLUTCH CYLINDER MTG . 2 CLUTCH MASTER CYLINDER - VEE 8 350 1 CLUTCH MASTER CYLINDER - VEE 8 420 1 1 CLUTCH MASTER CYLINDER - VEE 6 280 PEDAL BOX 1
193 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
J9
DESCRIPTION : BRAKES - PEDAL BOX - ALL MODELS - AUTOMATIC TRANSMISSION COMMENTS : L .H .D . & R .H .D. DATE OF ISSUE - 1/5/86 ITEM
1 2 3 4 5 6 7 8 9 10 11 12 13 14 14 15 16 17 18 19 20 21 22 23 24 24 24 24 25 26 27 28 29
PART NO .
027U 027U 025U 035U 025M 025W 025U 025J 125Q 025W 025W 025W 025U 035U 025U 025W 025W 025W 025W 025W 025U 025U 025J 025J 035E 025E 125E 035E 025J 025J 025W 025W 025J
270A 415A 334A 344A 019A 013A 416A 020A 053A 021A 118A 117A 130A 339A 338A 018A 009A 064A 005A 006A 332A 333A 054A 145A 095A 002A 155A 644A 017A 082A 013A 051A 146A
DATE REVISED DESCRIPTION
DRAWING REFERENCE 195 QUANTITY
RUBBER - BRAKE PEDAL 1 BRAKE PEDAL - AUTOMATIC 1 BUSH - PEDAL PIVOT 2 SPRING - PEDAL RETURN 1 SWITCH - BRAKE LIGHR WARNING 1 11I10 PLAIN WASHER 1 SPLIT PIN - PIVOT ROD RETAINER 1 RETAINER - CLIVIS PIN 1 CLEVIS PIN - BRAKE PEDAL 1 118 PLAIN LOCK NUT 1 PLAIN LOCKNUT - THROTTLE STOP 1 M6 X 25 SCREW - THROTTLE STOP 1 RUBBER - PEDAL - TVR LOGO 1 ACCELERATOR PEDAL ASSEMBLY - VEE 8 1 ACCELERATOR PEDAL ASSEMBLY- VEE 6 1 M12 NYLOC NUT - BRAKE LIGHT SWITCH MTG . 1 1,18 X 35 BOLT - BOX/BODY MOUNTING 2 PLAIN WASHER - BOX/BODY MOUNTING 2 118 NYLOC NUT - SERVO MOUNTING 4 118 PLAIN WASHER - SERVO MOUNTING 5 PEDAL BOX 1 PIVOT PIN - BRAKE PEDAL 1 HOSE - SERVO - VACUUM A/R KIT - SERVO NON RETURN VALVE 1 ACCELERATOR CABLE - VEE 8 1 ACCELERATOR CABLE - VEE 6 R .H .D . 1 ACCELERATOR CABLE - VEE 6 L .H .D . 1 ACCELERATOR CABLE - VEE 8 METAL TYPE 1 SERVO ASSEMBLY - GIRLING 1 MASTER CYLINDER - BRAKES 1 M10 PLAIN WASHER 2 M10 PLAIN NUT 2 KIT - SERVICE - SERVO
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION : COOLING SYSTEM - RADIATOR & HOSES COMMENTS :
1980
SERIES
DATE OF ISSUE ITEM
PART NO .
1
SECTION
K1
- 280I
280I MODELS ONLY DATE
REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
K2
DESCRIPTION : COOLING SYSTEM - ENGINE & HOSES - 280I fi COMMENTS : 2801 FEDERAL & EUROPEAN MODELS TO VIN SA9DH28POFB019442 - 1985 DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
28A REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION : COOLING SYSTEM - 280I MODELS
SECTION
K3
- RADIATOR IN NOSE CONE
COMMENTS : 2801 FEDERAL & EUROPEAN FROM VIN SA9DH28P7FB019454 - 1985 DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
28 REMARKS
SECTION
TVR ENGINEERING LIMITED PARTS CATALOGUE .
K4
DESCRIPTION : COOLING SYSTEM - RADIATOR & COOLING FANS COMMENTS : 2801 FEDERAL WITH0 A/C, 350I WITH A/C, ALL 390/420 MODELS 2 FANS DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
245 REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
K5
DESCRIPTION : COOLING SYSTEM - RADIATOR & COOLING FAN r COMMENTS : 280I EUROPEAN MODEL, 350I NON A/C MODELS DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
K6
DESCRIPTION : COOLING SYSTEM - RADIATOR & HOSES - 350I MODELS r
-
COMMENTS : L .H .D . SET UP DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
K7
DESCRIPTION : COOLING SYSTEM - RADIATOR & HOSES - 3501 MODELS COMMENTS : R .H .D . SET UP DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
L1
DESCRIPTION : FUEL SYSTEM - TANKS, HOSES & PUMPS - 280I f COMMENTS : TWIN FILLERS UP TO CHASSIS NUMBER DH5256FI - 1980/81 DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
L2
DESCRIPTION : FUEL SYSTEM - TANKS, HOSES & PUMP - 2801 FEDERAL & EUROPEAN COMMENTS : 280I FROM CHASSIS kNUMBER DH5258FI - 1981 DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
L3
DESCRIPTION : FUEL SYSTEM - TANKS, HOSES & PUMP - 350I COMMENTS : EUROPEAN VEE 8 MODELS FROM CHASSIS NUMBER DH5507RI - 1983 DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION : ELECTRICS - RADIO CONSUL SWITCHES
SECTION
Ml
- EUROPEAN
COMMENTS : SERIES 1 2801 MODELS - 1980/1981 DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
M2
DESCRIPTION : ELECTRICS - RADIO CONSUL SWITCHES - FEDERAL & EUROPEAN COMMENTS : ALL MODELS TO VIN TV9RF28PXEBDH1216 - 1984 DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
M3
DESCRIPTION : ELECTRICS - RADIO CONSUL SWITCHES - FEDERAL & EUROPEAN COMMENTS : ALL MODELS FROM VIN TV9RF28P1EBDH1217 & CH . NO . 2FH5878FI - 1984 DATE OF ISSUE ITEM
PART NO .
DATE REVISED
DRAWING REFERENCE
DESCRIPTION
PLEASE NOTE - DRAWING TO BE ISSUED FOR PART-M3
_
QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
M4
DESCRIPTION : ELECTRICS - FUSEBOARD, RELAYS, HORNS, DIRECTION/LIGHT SWITCH r COMMENTS : SERIES 1 2801 EUROPEAN - FUSE/RELAY BOARD UNDER BONNET DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
M5
DESCRIPTION : ELECTRICS - FUSEBOARD & RELAY PANEL - FEDERAL & EUROPEAN COMMENTS : ALL MODEL VARIATIONS WITH BOARD LOCATED UNDER DASHBOARD. DATE OF ISSUE ITEM
PART NO .
DATE REVISED
DRAWING REFERENCE
DESCRIPTION
QUANTITY
I
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
DESCRIPTION : ELECTRICS - FUSEBOARD - FEDERAL & EUROPEAN
M6
- NOVEMBER 1985
A
COMMENTS : ALL MODEL LOCATED REAR OF GLOVEBOX FROM VIN SA9DH28PXGB19001 DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
PLEASE NOTE - DRAWING TO FOLLOW
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
M7
DESCRIPTION : ELECTRICS - WINDOW REGULATOR, HORNS, DIRECTION/LIGHT SWITCH COMMENTS : ALL MODELS WHERE APPLICABLE DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
M8
DESCRIPTION : ELECTRICS - MIRRORS, LOUDSPEAKERS, ELECTRIC AERIAL A
COMMENTS : ALL MODELS - WHERE APPLICABLE DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY REMARKS
SECTION
TVR ENGINEERING LIMITED PARTS CATALOGUE .
M9
DESCRIPTION : ELECTRICS - WIPER MOTOR, ARM & WASHER A
COMMENTS : ALL MODELS - WHERE APPLICABLE DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
DESCRIPTION : ELECTRICS - LIGHTS - FRONT,
REAR & SIDE MARKER
R
COMMENTS : ALL MODELS INCLUDING FEDERAL WHERE APPLICABLE DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
M11
DESCRIPTION : ELECTRICS - REAR LIGHTS - ALL FIXEDHEAD MODELS & Jr.
COMMENTS : 280I TO VIN DH1238 OCT 85, 350I SERIES 1 TO DH6029RI JUNE 85 DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION : ELECTRICS - REAR LIGHTS
SECTION
M12
- 350I/390 SERIES 11 MODELS
COMMENTS : 3501/390/420 FROM 'CHASSIS NUMBER - DH128ORI APRIL 1985 DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION : ELECTRICS - REAR LIGHTS
SECTION
- 280I SERIES 1
M13
- 11 MODELS
COMMENTS : 280I FROM VIN TV9RF28P9FBDH1239 - OCTOBER 1985 DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
M14
DESCRIPTION : ELECTRICS - FRONT & INDICATOR LIGHTS - 420 SEAC MODEL COMMENTS: DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
i
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION : ELECTRICS - FEDERAL COMMENTS : DATE OF ISSUE ITEM
PART NO .
SECTION
M15
& EUROPEAN SPECIFICATION FLAIRED MIRRORS
' DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
M16
DESCRIPTION : ELECTRICS - EMISSION CONTROL EQUIPMENT - 2801 FEDERAL ONLY e.
COMMENTS: DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING SECTION LIMITED PARTS CATALOGUE. DESCRIPTION : INSTRUMENTS ; STEWART WARNER TYPE COMMENTS : ALL MODELS TO DH525EFI - 1981 DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
N2
DESCRIPTION : INSTRUMENTS - SMITHS TYPE - L .H .D . & R .H .D. COMMENTS : ALL MODELS TO DATE OF ISSUE ITEM
PART NO .
fr VIN TV9RF28P3FBDH1222 CH . NO . DH5901FI NOV 84 DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION : INSTRUMENTS - VDO TYPE - L .H .D .
SECTION
N3
& R .H .D.
COMMENTS : ALL MODELS FROM VI§ TV9RF28P3FBDH1223 CH . NO . DH5902FI NOV 84 DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
P1
- TO MAY 1981 DESCRIPTION : HEATING & VENTILATION - INTERIOR CONTROLS fr COMMENTS :SERIES 1 280I WITH 2 VENT OUTLET & TWO BLOWER MOTORS TO FH5221F12 DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED
PARTS
CATALOGUE .
SECTION
P2
DESCRIPTION : HEATING & VENTILATION - THREE VENT OUTLET
- FROM MAY 1981
COMMENTS :FEDERAL WITH A/C - EUROPEAN WITH SINGLE BLOWER
MOTOR
DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
DESCRIPTION : HEATING & VENTILATION - FOUR VENT OUTLET
P3
- FROM OCT . 1984
F'.
COMMENTS :REVISED HEATER BOX - FROM VIN TV9RF28P1EBDH1217 CH NO DH5842RI DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
P4
DESCRIPTION : AIR CONDITIONING CONTROLS - ENGINE BAY - 280I MODELS fr COMMENTS :280I FEDERAL UP TO VIN SA9DH28P0FB019442 DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
P5
DESCRIPTION : AIR CONDITIONING CONTROLS - ENGINE BAY - 280I MODELS COMMENTS :280I FEDERAL FROM VIN SA9DH28P7FB019425 DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
P6
DESCRIPTION : AIR CONDITIONING CONTROLS - ENGINE BAY - 280I MODELS COMMENTS :ADDITIONAL AIR CONDITIONING IDLE VALVE FROM APRIL 1985 DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
Q1
DESCRIPTION : CLUTCH - 280I SERIES 1 MODELS 1980 t COMMENTS : EARLY HYDRAULIC TYPE AND R .H .D . CABLE OPERATED TYPE DATE OF ISSUE ITEM
PART NO .
DATE REVISED
DRAWING REFERENCE
DESCRIPTION
ILLUSTRATION TO FOLLOW
QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
Q2
DESCRIPTION : CLUTCH - 2801 1983 FEDERAL & 1985 EUROPEAN A.
COMMENTS : HYDRAULIC OPERATED MASTER AND SLAVE CYLINDER DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
Q3
DESCRIPTION : CLUTCH - 2801 HYDRAULIC SLAVE CYLINDER COMMENTS BREAKDOWN : COMPONENT DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
Q4
DESCRIPTION : CLUTCH - 280I/350I/390 HYDRAULIC MASTER CYLINDER COMMENTS : COMPONENT BREAKDOWN DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE _
QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
Q5
DESCRIPTION : CLUTCH HOUSING - 350I/390 r. COMMENTS : ALL MODELS DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION Q6
DESCRIPTION : CLUTCH PLATE & FLYWHEEL - 350I/390 COMMENTS : ALL MODELS DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
Q7
DESCRIPTION : CLUTCH HYDRAULIC SLAVE CYLINDER - 350I/390 COMMENTS : COMPONENT BREAKDOWN DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
Rl
DESCRIPTION : DIFFERENTIAL, DRIVESHAFTS & CARRIERS COMMENTS :350 TO SA9DH35P3GB019333 390 TO SAPDH35P7GB019108 JUNE 86/OCT 85 DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
R2
DESCRIPTION : DIFFERENTIAL, DRIVESHAFTS & CARRIERS - 350I/390/420 FROM A
COMMENTS :390/420 - SA9DH35P7GB019109 350I - SA9DH35P3GBO19109 DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION R3
DESCRIPTION : DIFFERENTIAL ASSEMBLY - ALL MODELS COMMENTS: DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION : DIFFERENTIAL ASSEMBLY
SECTION
R4
- INTERNALS - ALL MODELS
F
COMMENTS : NON POWER LOCK DIFFERENTIALS DATE OF ISSUE ITEM
PART NO .
i
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION : DIFFERENTIAL ASSEMBLY
SECTION
R5
- INTERNALS - ALL MODELS
A.
COMMENTS : POWER LOCK DIFFERENTIALS DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
Si
DESCRIPTION : EXHAUST - 2801 EARLY MODELS COMMENTS : EXHAUST BOX BELOW OHASSIS/PROPSHAFT DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
SECTION
TVR ENGINEERING LIMITED PARTS CATALOGUE .
S2
DESCRIPTION : EXHAUST - 280I EARLY MODELS 1981 A
COMMENTS : EXHAUST BOX ABOVE PROPSHAFT DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE _
QUANTITY
REMARKS
PLEASE NOTE - NO DRAWING OR SPARE PARTS ARE NOW AVAILABLE FOR THESE MODELS - CONTACT THE FACTORY FOR ADDITIONAL DETAILS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
DESCRIPTION : EXHAUST - 2801 UNDER FLOOR DOUBLE SYSTEM
S3
- EUROPEAN
F
COMMENTS : FRONT PIPES TO 1ST . BOXES RUN REARWARD DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
FROM MANIFOLDS. DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE . DESCRIPTION : EXHAUST COMMENTS :
280I UNDER FLOOR DOUBLE SYSTEM
S4
- FEDERAL/EUROPEAN
FRONT PIPES TO 1ST . BOXES RUN FORWARD FROM MANIFOLDS.
DATE OF ISSUE ITEM
SECTION
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
S5
DESCRIPTION : EXHAUST - 3501 SINGLE PIPE SYSTEM - SERIES 1 COMMENTS : CAST IRON MANIFOLDS WITH SINGLE PIPE OUTLET AT REAR OF VEHICLE. DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
S6
DESCRIPTION : EXHAUST - 3501/390 TWIN PIPE SYSTEM - SERIES 11 COMMENTS : TUBULAR MANIFOLDS WITH TWIN REAR BOXES - 390 DIFFERENT BORE PIPE DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
S7
DESCRIPTION : EXHAUST - 350I SINGLE BOX SYSTEM - SERIES 11 - ENGLISH COMMENTS : TWIN PIPE OUTLET AF RIGHT OF CAR WITH SINGLE PIPE TO REAR DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
S8
DESCRIPTION : EXHAUST - 350I SINGLE BOX SYSTEM - SERIES 11 - EUROPEAN COMMENTS : TWIN PIPE OUTLET AT RIGHT OF CAR WITH SINGLE BOX AT REAR OUTLET DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
S9
DESCRIPTION : EXHAUST - 3501 SINGLE BOX SYSTEM - SERIES 11 - PROPOSED SWISS COMMENTS : TWIN PIPE OUTLET AT RIGHT OF CAR WITH TWO BOXES DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
AT REAR
OUTLET
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
S10
DESCRIPTION : EXHAUST - 390/420 TWIN BOX SYSTEM - ENGLISH SPECIFICATION ft COMMENTS : SINGLE PIPE OUTLET AT REAR WITH ONE BOX IN REAR SECTION DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
U1
DESCRIPTION : HARD TRIM - DOOR - FIXEDHEAD - EUROPEAN COMMENTS : DOOR BEAM CONSTRUCTION SAME AS CONVERTIBLE DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
U2
DESCRIPTION : HARD TRIM - DOOR - CONVERTIBLE - FEDERAL SPECIFICATION COMMENTS: DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
U3
DESCRIPTION : HARD TRIM - GLASS - FIXEDHEAD COMMENTS: DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS
CATALOGUE .
SECTION
U4
DESCRIPTION : HARD TRIM - RUBBER SEALS, IMPACT BEAMS, SUPPORTS ETC. COMMENTS: DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
U5
DESCRIPTION : HARD TRIM - SEATS AND RUNNERS COMMENTS : DATE OF ISSUE ITEM
PART NO .
f DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
V1
DESCRIPTION : SOFT TRIM - CARPET - FIXEDHEAD SERIES 11 TYPE COMMENTS: DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
TVR ENGINEERING LIMITED PARTS CATALOGUE .
SECTION
V2
DESCRIPTION : SOFT TRIM - CARPET - CONVERTIBLE MODELS COMMENTS: DATE OF ISSUE ITEM
PART NO .
DATE REVISED DESCRIPTION
DRAWING REFERENCE QUANTITY
REMARKS
View more...
Comments
