Service Manual W11296289 Side X Side Refrigerator PDF
December 24, 2022 | Author: Anonymous | Category: N/A
Short Description
Download Service Manual W11296289 Side X Side Refrigerator PDF...
Description
R-126
SERVICE MANU MANUAL AL
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
W11296289
FORWARD This Whirlpool Service Manual (Part No. W11296289), provides the In-Home Service Profession Professional al with service informaon for the “Whripool®, Maytag®, Amana®, and IKEA® Refrigerators.” The Wiring Diagram used in this Service Manual is typical and should be used for training purposes only. Always Always use the Wiring Diagram supplied with the product tech sheet when servicing the refrigerator. For specic operang and installaon installaon informaon on the model being serviced, refer to the “Use and Care Guide” or “Installaon Instrucons” provided with the refrigerator.
GOALS AND OBJECTIVES The goal of this Service Manual is to provide informaon that that will enable the In-Home Service Ser vice Professional to properly diagnose malfuncons and repair the “Whripool®, Maytag®, Amana®, and IKEA® Refrigerators.” The objecves of this Service Manual are to: • Understand and follow proper safety precauons. • Successfully troubleshoot and diagnose malfuncons. • Successfully perform necessary repairs.
WHIRLPOOL CORPORATION assumes no responsibility for any repairs made on our products by anyone other than authorized In-Home Service Professionals.
©2018 Whirlpool Corporaon. Benton Harbor, MI 49022
ii
n
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
TABLE OF CONTENTS
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigera Refrigerators tors S ECTION 1: GENERAL INFORMATION ........................................................................101 REF RIG ERATOR SAF ET ETY Y .................................... ...................................................... ..................................... ..................................... ..................................... ......................... ...... 102 PRODUCT SPECIFICATIONS.................. SPECIFICATIONS..................................... ..................................... ..................................... ..................................... ..................................... ................... 103 PRODUC PRO DUC T FEATUR ES ............................................... ................................................................. ..................................... ..................................... ..................................... ................... 111 MODEL & SERIAL NUMBER LOCATION ............................................................................................. 112 TEC H SHE ET LOC ATION .................................... ....................................................... ..................................... ..................................... ...................................... ......................... ...... 112 MOD EL NO NOMEN MEN CL CLATURE ATURE ................................................ .................................................................. ..................................... ...................................... ............................ ......... 113
............................... ............................... ............................... ............................... ............................ .............201 S ECTION 2: DIAGNOSTICS ............... SAF ETY .................. .................................... ..................................... ..................................... ..................................... ..................................... ..................................... ................................ ............. 202 DIAGNO DIA GNO STI CS MOD E .......................................... ............................................................. ...................................... ..................................... ..................................... ...................... ... 203 SAL ES DE DEMO MO MOD E .......................... ............................................ ..................................... ..................................... ..................................... ...................................... ...................... ... 209
S ECTION 3: COMPONENT TESTING ................ ............................... ............................... ............................... ............................ .............301 SAF ETY .................. .................................... ..................................... ..................................... ..................................... ..................................... ..................................... ................................ ............. 302 WIRING WIR ING DIA DIAGRA GRA M ..................................... ........................................................ ..................................... ..................................... ..................................... ............................... ............. 303 COM PON ENT LOC ATION .................. ..................................... ..................................... ..................................... ..................................... ..................................... ...................... ... 309
S ECTION 4: COMPONENT ACCESS .............................................................................401 REMOVING THE FRONT WHEEL........................................................................................................ 402 ACCESSING INTERIOR OF UNIT ........................................................................................................ 403 REM OVI OVING NG THE DAMP ER .......................... ............................................. ..................................... ..................................... ..................................... ............................... ............. 403 REMOVING THE FREEZER SHELF ...................................................................................................... 405 ACCES SING THE FREE ZER EVAPORATOR AND COMPO NENTS ......... .............. ......... ......... ......... ......... .......... .......... ......... ......... ......... ...... .. 405 ..................................... ..................................... .................................... ..................407 ACCESSING THE MACHINE DISPENSER AREA REMOVING UI .................. 410 ACCESSING THE COMPARTMENT ....................................................................................
Whirlpool®, Maytag®, Amana® , & IKEA® Refrigerators
n
iii
Notes
iv
n
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
GENERAL INFORMATION
Section 1: General Information This secon provides general safety, parts, and informaon for the “Whirlpool®, Maytag®, Amana®, and IKEA® Refrigerators.” ■
Refrigerator Safety
■
Product Specicaons
■
Product Feature • Control Panel
■
Model & Serial Label • Locaon • Model Nomenclature
■
Tech Sheet Locaon
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
1-1 1 n 1-
GENERAL INFORMATION
Refrigerator Safety Your safety and the safety of others are very important. We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety messages. This is the safety alert symbol. This symbol alerts you to potential hazards that can kill or hurt you and others. All safety messages will follow the safety alert alert symbol and either the word “DANGER” or “WARNING.” “WARNING.” These words mean:
DANGER WARNING
You can be killed or seriously injured if you don't immediately follow instructions. You can be killed or seriously injured if you don't follow instructions.
All safety messages will tell you what the potential potential hazard is, tell you how to reduce the chance of injury, and tell you what can happen if the instructions are not followed.
IMPORTANT SAFETY INSTRUCTIONS WARNING: To
reduce the risk of fire, electric shock, shock, or injury when using your refrigerator, follow these basic basic precautions:
Plug into a grounded 3 prong outlet. Connect to a potable water supply only.
Do not remove ground prong.
Do not use an adapter.
Do not use an extension cord.
Disconnect power before servicing.
Replace all parts and panels before operating.
Remove doors from your old refrigerator
This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge, unless they have been given supervision or instruction conce concerning rning use of the appliance by a person responsible for their safety.
Remove doors from your old refrigerator.
Use nonflammable cleaner.
Keep flammable materials and vapors, such as gasoline, away from refrigerator. Use two or more people to move and install install refrigerator. Disconnect power before installing ice maker (on ( on icemaker kit ready models only). Use a sturdy glass when dispensing ice (on some models). Do not hit the refrigerator glass doors (on some models). Children should be supervised to ensure that they do not play with the appliance.
SAVE THESE INSTRUCTIONS
1-2 12 n Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
GENERAL INFORMATION
Product Specifications Amana® 36" Side by Side Refrigerator with Dual Pad External Ice and Water Dispenser AHAM Volumes and Shelf Area Freezer Volume (Cu Ft)
9.11
Refrigerator Volume (Cu Ft)
15.46
Total Volume (Cu Ft)
24.6
Dimensions
Capacity (FT3, Cu Ft)
24.57
Cabinet Width (IN, inches)
351/2
Cutout Depth (IN, inches)
271/2
Cutout Height (IN, inches)
693/8
Cutout Width (IN, inches)
36
Depth Closed Excluding Handles (IN, inches)
315/8
Depth Closed Including Handles (IN, inches)
341/8
Depth Excluding Doors (IN, inches)
28
Depth With Door Open 90 Degree (IN, inches)
493/8
Depth (IN, inches)
345/8
Height to Top of Cabinet (IN, inches)
685/8
Height to Top of Door Hinge (IN, inches)
691/4
Height (IN, inches)
695/8
Width (IN, inches)
357/8
Descripon Type of Refrigerator
Side by Side
Details
Advance Foam Insulaon
NA
Cooling Type
Single Evaporator
Exterior Base Grille Color
Black/White
Cabinet Color
Black/White
Cabinet Finish Door Color
Textured Black/Stainless Steel/White
Door Finish
Smooth
Door Style
Contour
Door Swing
NA
Handle Color
Black/Stainless Steel/White
Handle Material
Metal
Handle Type
Reach Through Handle
Hidden Hinge
Yes
Number of Doors
2
Levelers
2 Black
Wheels
4-Natural
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
1-3 3 n 1-
GENERAL INFORMATION
Controls
Automac Defrost
Yess Ye
Locaon of Controls
Exterior Dispenser
Temperature Range
-5/+5 FC 33/45 RC
Type of Control
Electronic Touch
Water Filter Indicator/Reset
Yes
Connected Appliances
No
Refrigerator Compartment Number of Interior Shelves
4
Convenonal Shelves
1 Fixed Full-Width Glass 3 Adjustable Full-Width Glass
Spill-Proof Glass Shelves
No
Shelf Supports
Molded
Humidity-Controlled Drawers
1 Full-Width
Non-Climate Control Drawers
1 Full-Width
Temperature-Controlled Drawers
No
Door Bins
1 Dairy 1 Fixed Full-Width 3 Adjustable Gallon
Supplementary Containers
No
Lighng
Incandescent
Liner Finish
White Opaque
Freezer Compartment
Door Type
Swing
Shelves
3 Fixed Full-Width Wire
Freezer Number of Shelves
3
Freezer Drawer/Basket
1 Full-Width Lower Plasc
Door Bins
1 Fixed Paral 3 Fixed Full-Width
Light
Incandescent
Dispenser
Dispenser Type Dispenser Opons
Exterior Ice and Water Filtered Water Measured/Metered Fill
Types of Ice
Crushed/Cubed
Dispenser Pad Color
Black
Icemaker Icemaker
Factory Installed
Icemaker Locaon
Freezer
Electrical Amps
7.2
Hz
60
Volts
110
1-4 14 n Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
GENERAL INFORMATION
Whirlpool® 36" Wide Side by Side Refrigerator - 25 Cu Ft AHAM Volumes and Shelf Area Freezer Volume (Cu Ft)
9.11
Refrigerator Volume (Cu Ft)
15.46
Total Volume (Cu Ft)
24.6
Dimensions
Capacity (FT3, Cu Ft)
24.57
Cabinet Width (IN, inches)
357/8
Dep eptth Clo Clossed Exclu lud din ing g Ha Hand ndle less (IN (IN,, inc inche hes) s) Dep eptth Clo Clossed In Incclu ludi ding ng Hand ndle less (IN (IN,, inc inche hes) s)
315/8 335/8
Depth Excluding Doors (IN, inches)
28
Dept De pth h Wit With h Doo Doorr Ope Open n 90 90 Deg Degre ree e (IN (IN,, inc inche hes) s)
495/16
Depth (IN, inches)
335/8
Height to Top of Cabinet (IN, inches)
685/8
Height to Top of Door Hinge (IN, inches)
691/4
Height (IN, inches)
695/8
Width (IN, inches)
357/8
Descripon Type of Refrigerator
Side by Side
Details Advance Foam Insulaon
NA
Cooling Type
Single Evaporator
Exterior Base Grille Color
White/Black/Grey/Biscuit
Cabinet Color
White/Black/Grey/Biscuit
Cabinet Finish
Textured
Door Color
White/Black/Stainless Steel/Sunset Bronze White/Black/Stainless Bronze/Fingerprint /Fingerprint Resistant Stainless Steel/ Biscuit
Door Finish
Smooth
Door Style
Contour
Door Swing
NA
Handle Color Handle Material
White/Black/Stainless Steel/Biscuit/Fingerprint Resistant Stainless Steel Stainless Steel
Handle Type
Reach Through Handle
Hidden Hinge
Yes
Number of Doors
2
Controls
Automac Defrost
Yes
Locaon of Controls
Interior Up Front/Interior/Exterior Dispenser
Type of Control
Electronic Touch/Tap Touch
Water Filter Indicator/Reset
Yes
Connected Appliances
No
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
1-5 5 n 1-
GENERAL INFORMATION
Refrigerator Compartment
Number of Interior Shelves
4
Convenonal Shelves
1 Fixed Full-Width Glass 3 Adjustable Full-Width Glass
Shelf Supports
Molded
Humidity-Controlled Drawers
1 Full-Width
Non-Climate Control Drawers
1 Full-Width
Temperature-Controlled Drawers
No
Door Bins
1 Dairy 1 Fixed Full-Width 3 Adjustable Gallon
Supplementary Containers
No/Can Caddy Bin Ulity Compartment
Lighng
LED
Freezer Compartment
Door Type
Swing
Shelves
1 Fixed Full-Width Plasc 4 Fixed Full-Width Wire or 3 Fixed Full-Width Glass
Freezer Number of Shelves
3 or 4 or 5
Freezer Drawer/Basket
1 Full-Width Lower Plasc
Door Bins
4 Fixed Full-Width or 1 Fixed Paral 3 Fixed Full-Width
Light
LED
Dispenser
Dispenser Type
No Dispenser/Exterior Ice and Water
Dispenser Opons
Filtered Water Ice Dispenser Lock Night Light
Types of Ice
Crushed/Cubed
Icemaker Icemaker
Oponal/Factory Installed
Icemaker Kit Part Number
ECKMF95
Icemaker Locaon
Freezer
Electrical Hz
60
1-6 16 n Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
GENERAL INFORMATION
Whirlpool® 33" Wide Side by Side Refrigerator - 22 Cu Ft AHAM Volumes and Shelf Area Freezer Volume (Cu Ft)
7.07
Refrigerator Volume (Cu Ft)
14.65
Total Volume (Cu Ft)
21.7
Dimensions
Capacity (FT3, Cu Ft)
21.72
Cabinet Width (IN, inches)
323/4
Depth Closed Excluding Handles (IN, inches)
315/8
Depth Closed Including Handles (IN, inches)
335/8
Depth Excluding Doors (IN, inches)
28
Depth With Door Open 90 Degree (IN, inches)
495/16
Depth (IN, inches)
335/8
Height to Top of Cabinet (IN, inches)
655/8
Height to Top of Door Hinge (IN, inches)
661/4
Height (IN, inches)
665/8
Width (IN, inches)
323/4
Descripon Type of Refrigerator
Side by Side
Details Advance Foam Insulaon
NA
Cooling Type
Single Evaporator
Exterior Base Grille Color
White/Black/Grey
Cabinet Color
White/Black/Grey
Cabinet Finish
Textured
Door Color
White/Black/Stainless Steel
Door Finish
Smooth
Door Style
Contour
Door Swing
NA
Handle Color
White/Black/Stainless Steel
Handle Material
Metal
Handle Type
Reach Through Handle
Hidden Hinge
Yes
Number of Doors
2
Controls
Automac Defrost
Yes
Locaon of Controls
Interior
Type of Control
Electronic Touch
Connected Appliances
No
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
1-7 7 n 1-
GENERAL INFORMATION
Refrigerator Compartment
Number of Interior Shelves
4
Convenonal Shelves
1 Fixed Full-Width Glass 3 Adjustable Full-Width Glass
Shelf Supports
Molded
Humidity-Controlled Drawers
1 Full-Width
Non-Climate Control Drawers
1 Full-Width
Temperature-Controlled Drawers
No
Door Bins
1 Dairy 1 Fixed Full-Width 3 Adjustable Gallon
Supplementary Containers
No
Lighng
LED
Liner Finish
White Opaque
Freezer Compartment
Door Type
Swing
Shelves
4 Fixed Full-Width Wire
Freezer Number of Shelves
4
Freezer Drawer/Basket
1 Full-Width Lower Plasc
Door Bins
4 Fixed Full-Width
Light
LED
Dispenser
Dispenser Type
No Dispenser
Icemaker Icemaker
Oponal
Icemaker Locaon
Freezer
Icemaker Kit Part Number
ECKMF95
Electrical Amps
7.2
Hz
60
Volts
110
1-8 18 n Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
GENERAL INFORMATION
Whirlpool® 33" Wide Side by Side Refrigerator - 21 Cu Ft AHAM Volumes and Shelf Area Freezer Volume (Cu Ft)
6.77
Refrigerator Volume (Cu Ft)
14.65
Total Volume (Cu Ft)
21.4
Dimensions
Capacity (FT3, Cu Ft)
21.4
Cabinet Width (IN, inches)
323/4
Dept De pth h Cl Clos osed ed Ex Excl clud udin ing g Han andl dles es (I (IN, N, in inch ches es))
315/8
Dep epth th Clo lose sed d Inc Inclu lud din ing g Han Handl dles es (IN IN,, in inche hes) s)
335/8
Depth Excluding Doors (IN, inches)
28
Dept De pth h Wit With h Doo Doorr Ope Open n 90 90 Deg Degre ree e (IN (IN,, inc inche hes) s)
495/16
Depth (IN, inches)
335/8
Height to Top of Cabinet (IN, inches)
655/8
Height to Top of Door Hinge (IN, inches)
661/4
Height (IN, inches)
665/8
Width (IN, inches)
323/4
Descripon Type of Refrigerator
Side by Side
Details Advance Foam Insulaon
NA
Cooling Type
Single Evaporator
Exterior Base Grille Color
White/Black/Grey/Biscuit
Cabinet Color
White/Black/Grey/Biscuit
Cabinet Finish
Textured/Smooth
Door Color
White/Black/Stainless Steel/Fingerprint Resistant Stainless Steel/Biscuit
Door Finish
Smooth
Door Style
Contour
Door Swing
NA
Handle Color
White/Black/Stainless Steel/Biscuit/Print Resist Stainless Steel
Handle Type
Reach Through Handle
Hidden Hinge
Yes
Number of Doors
2
Controls
Automac Defrost
Yes
Locaon of Controls
Exterior Dispenser/Interior Up Front
Temperature Range
-5/+5 FC 33/45 RC
Type of Control
Electronic Touch
Water Filter Indicator/Reset
Yes
Connected Appliances
No
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
1-9 9 n 1-
GENERAL INFORMATION Refrigerator Compartment
Number of Interior Shelves
4
Convenonal Shelves
1 Fixed Full-Width Glass 3 Adjustable Full-Width Glass
Shelf Supports
Molded
Humidity-Controlled Drawers
1 Full-Width
Non-Climate Control Drawers
1 Full-Width
Temperature-Controlled Drawers
No
Door Bins
1 Dairy Full-Width 1 Fixed 3 Adjustable Gallon
Supplementary Containers
No/Can Caddy Bin Ulity Compartment
Lighng
LED
Freezer Compartment
Door Type
Swing
Shelves
3 Adjustable Full-Width Glass or 3 Fixed Full-Width Wire
Freezer Number of Shelves
3
Freezer Drawer/Basket
1 Full-Width Lower Plasc
Door Bins
3 Fixed Full-Width
Light Dispenser
LED
Dispenser Type
Exterior Ice and Water
Dispenser Opons
Filtered Water Ice Dispenser Lock Measured/Metered Fill Night Light
Types of Ice
Crushed/Cubed
Icemaker Icemaker
Factory Installed
Icemaker Locaon
Freezer
Electrical Hz
60
1-10 110 n Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
GENERAL INFORMATION
Product Features CONTROL PANEL
Refrigerator Refrigera tor Control: n n
Press Refrigerator Temp to view the current set point for the refrigerator. Press Refrigerator Temp again to adjust the set point. The seng will increase by 1 bar with each press of the buon, returning to 1 bar aer reaching 5 bar. Aer 2 minutes of inacvity, any changes will be saved and the display will return to the home screen.
Freezer Control: n
Press Freezer Temp to view the current set point for the freezer. n Press Freezer Temp again to adjust the set point. The seng will increase by 1 bar with each press of the buon, returning to 1 bar aer reaching 5 bar. Aer 2 minutes of inacvity, any changes will be saved and the display will return to the home screen.
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
1-11 11 n 1-
GENERAL INFORMATION
Model & Serial Number Location
Tech Sheet Location
1-12 112 n Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
GENERAL INFORMATION
Model Nomenclature MODEL NUMBER
W
R
S
3 1
5 S
N
H
B
INTERNATIONAL SALES OR MARKETING CHANNEL
Brand W = Whirlpool Platform R = Freestanding Refrigeration S = Specialty Refrigeration U = Undercounter Refrigeration Refrigeration Z = Freestanding Freezer
Sub Platform/Fuel T = Top Freezer S = Side by Side B = Bottom Freezer F = French Door X = FD Double Drawer X = All Freezer V = Vertical Pantry Series 1 = OPP 3 = Low Line 5 = Mid Line 7= High (GOLD) 9= Hero (GOLD)
Feature Level/Key Feature Feature Level (0-9) OR Derivative (Top Mount) Feature Level/Key Feature 0 = 10 OR 20 OR 30 Cu Ft 1 = 11 OR 21 Cu Ft 2 = 12 OR 22 Cu Ft 3 = 13 OR 23 Cu Ft 4 = 14 OR 24 Cu Ft 5 = 15 OR 25 Cu Ft 6 = 16 OR 26 Cu Ft 7 = 17 OR 27 Cu Ft C = Counter Depth F = Flat S = Smooth Contour T = Textured X = Light Texture, Contour O = Overlay K = Trim Kit B = Beveled Edge I = In-Door-Ice N = Non-Dispense W = Internal Water D = Dispense Ice & Water S = Shaved Ice C = Crushed Ice F = Field Install Ice Maker, No Water YEAR PF MARKET INTRODUCTION F = 2016 G = 2017 H = 2018 J = 2019 COLOR W = White T = Bisque/Biscuit B = Black S = Black On Stainless
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
1-13 13 n 1-
GENERAL INFORMATION
Notes
1-14 114 n Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
DIAGNOSTICS
Section 2: Diagnostics This secon provides diagnosc mode and sales mode informaon for the “Whirlpool®, Maytag®, Amana®, and IKEA® Refrigerators.”
■
Safety
■
Diagnoscs Mode
■
Sales Mode
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
n 2-1
DIAGNOSTICS
For Service Serv ice Technician Technician Use Only O nly Safety WARNING
DANGER
Electrical Shock Hazard
Electrical Shock Hazard Disconnect power before servicing.
Only authorized technicians should perform diagnostic voltage measurements.
Replace all parts and panels before operating.
After performing voltage measurements, disconnect power before servicing.
Failure to do so can result in death or electrical shock.
Failure to follow these instructions can result in death or electrical shock.
Voltage Measurement Safety Information When performing live voltage measurements, you must do the following:
Verify the controls are in the off position so that the appliance does not start when energized.
Allow enough space to perform the voltage measurements without obstructions.
Keep other people a safe distance away from the appliance to prevent potential injury.
Always use the proper testing equipment.
After voltage measurements, always disconnect power before servicing.
IMPORTANT : Electrostatic Discharge (ESD) Sensitive Electronics ESD problems are present everywhere. ESD may damage or weaken the electronic control assembly. The new control assembly may appear to work well after repair is finished, but failure may occur at a later date due to ESD stress.
Use an antistatic wrist strap. Connect wrist strap to green ground connection point or unpainted metal in the appliance -ORTouch your finger repeatedly to a green ground connection point or unpainted metal i n the appliance.
2-2
Before removing the part from its package, touch the antistatic bag to a green ground connection point or unpainted metal in the appliance.
Avoid touching electronic parts or terminal contacts; handle electronic control assembly by edges only.
When repackaging failed electronic control assembly in antistatic bag, observe above instructions.
n Whirlpool
®
, Maytag®, Amana®, & IKEA® Refrigerators
DIAGNOSTICS
For Service Se rvice Technician Technician Use Only Diagnostics Mode Service Informaon 1. 2. 3. 4. 5.
Compressor sucon and process stubs may not be interchanged. Refrigerant charge must be applied to high side only. Ice maker and water valve not original equipment on all models. NOTE: Ice maker cycle must be iniated electrically. Do not try to manually start the cycle. Part number can be found on the component.
*Normal operang condions are viewed when the air and temperature controls are at the mid-sing freezer secon 0 to -5°F and unit is cycling. NOTE: Wa and pressure readings will vary and are inuenced by the exisng condion of the appliance such as the iced-up evaporator, condion of the condenser, defrost cycle, pull-down me and customer use.
Serviceable Electrical Parts Matrix (Components By Cu Ft Size) 21 Cu Ft
Serviceable Parts
22 Cu Ft
25 Cu Ft
Waage
Resistance (Ω)
115 - 127 VAC 102
EGX60HLC
Compressor
W11045354
Run Windings
*
1-5
Start Device, Overload
See Note
Run Capacitor (If Equipped) Electric Air Bae Assembly
See Note See Note
Thermistor
See Note
User Interface Control
See Note
Main Control
See Note
Defrost Heater
See Note
550 - 650
Evaporator Fan Motor
See Note
2-9
Condenser Fan Motor
See Note
3 - 12
12 V DC 2.7 kΩ at 25°C
Serviceable Electrical Parts Matrix EGX60HLC
WATTAGE 115 - 127 VAC
EM3Y60HLP
WATTAGE 115 - 127 VAC
Compressor
W11045354
102
W11181053
109
Run Windings
-
-
Start Device, Overload
See Note
See Note
Run Capacitor (If Equipped)
See Note
See Note
Electric Air Bae Assembly
See Note
Thermistor
See Note
See Note
User Interface Control
See Note
See Note
Main Control
See Note
See Note
Defrost Heater
See Note
550 - 650
See Note
550 - 650
Evaporator Fan Motor
See Note
2-9
See Note
2-9
Condenser Fan Motor
See Note
3 - 12
See Note
3 - 12
Serviceable Parts
12 V DC
See Note
Resistance (Ω)
1-5
12 V DC 2.7 kΩ at 25°C
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
2-3
n
DIAGNOSTICS
For Service Serv ice Technician Technician Use Only O nly Performance Data * (Normal Operang Condions) AMB
System Pressure (PSIG)
Was
High Side
Low Side
EG Series 70°
140 +/- 20
95 +/- 20
- 7 To 3
90°
150 +/- 20
135 +/- 20
- 4 To 3
110°
170 +/- 20
185 +/- 20
- 2 To 4
EM3 Series 70°
120 +/- 20
120 +/- 20
- 6 To 3
90°
130 +/- 20
160 +/- 20
- 4 To 3
110°
140 +/- 20
220 +/- 20
- 2 To 4
Compressor Opons - Refer To Applicable Design (Oil cooler not presen presentt on all compressors) EMBRACO (OIL COOLER IS OPTIONAL)
EMBRACO
SUCTION TUBE SUCTION TUBE
PROCESS TUBE
DISCHARGE TUBE
DISCHARGE PROCESS TUBE OIL COOLER
EG SERIES
EM3 SERIES
Service Key Assignment O CRUSH
●
LED1
O
O
O
O
O
LED2
LED3
LED4
LED5
LIGHT
O CUBE
O
●
O
O
LOCK
LED6
LED7
LED8
O
LED9
O
LED10
SW1
SW2
SW3
SW4
SW5 During the rst ve minutes aer a power on, put seng temperature at the minimum posion for both RC and FC. Aerward, hold "FREEZER TEMP" and "ICE TYPE" keys for 3 seconds to enter service mode. Aer entering service mode, all LEDs will turn on to verify all LEDs can turn on. To proceed to service steps, a user shall press all 5 keys individually from le to right to turn o all LEDs and validate touch funcon. NOTE: For smooth operaon of user interface key acvaon, wait at least 1 second between each press, to let the system toggle between service steps.
KEYS
DESCRIPTION
SW2 = Light Key
Increment Key: Advance to next step
SW4 = Lock Key
Decrement Key: Go back to the previous step
SW5 = RC Temp Key Change Seng Key: Turn ON/OFF load, PAUSE/RUN specic test NOTE: For IDI model with twist tray ice maker, upon entry into service, an ice maker is enabled and a homing operaon is performed, this is to avoid of any other load interference when SANKYO IM is performing the Homing operaon. The LEDs on the FREEZER TEMP secon will show the step number while the LEDs above REFRIGERATION TEMP secon will show the feedback. Steps 29 to 35 apply only for models with twist tray maker in the door (IDI).
2-4
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
24
n Whirlpool
, Maytag , Amana , & IKEA Refrigerators
DIAGNOSTICS
For Service Se rvice Technician Technician Use Only Step 1
Step Code
Component
●
O
LED1
LED2 LED3 LED4 LED5
O
O
O
FC Se Sens nsor or
Acon
Feedback
Entry: Entr y: Dis Displ play ay st step ep num numbe berr & sta start rt sensor check. Do: Read the current temperature of the FC thermistor and compare the value. Exit: Stop sensor readings.
Open sensor display: ●
O
O
LED6
LED7
LED8 LED9
O
O
LED10
Short sensor display: O
O
●
LED6
LED7
LED8 LED9
Pass test display:
O
O
●
●
●
LED6
LED7
LED8 LED9
O
LED10
O
LED10
Sensor status blank unl gets a valid reading
2
O FF
3
●
●
O
LED1
LED2
LED3 LED4 LED5
NONE O
O
RC Sensor Step Code:
O
O
O
O
LED6
LED7
LED8 LED9
OFF
O FF
Entry: Display step number & start sensor check. Do: Read the current temperature of the RC thermistor and compare the value. Exit: Stop sensor readings.
Open sensor display: ●
O
O
LED6
LED7
LED8 LED9
O
O
LED10
O
LED10
Short sensor display: O
O
●
LED6
LED7
LED8 LED9
O
O
LED10
Pass test display: O
●
●
●
LED6
LED7
LED8 LED9
O
LED10
Sensor status blank unl gets a valid reading
4
OFF
5
●
●
●
O
LED1
LED2
LED3
LED4 LED5
NONE O
Defrost Sensor
O
O
O
O
LED6
LED7
LED8 LED9
OFF
O FF
Entry: Display step number & start sensor check. Do: Read the current temperature of the Defrost thermistor and compare the value. Exit: Stop sensor readings.
Open sensor display: ●
O
O
LED6
LED7
LED8 LED9
O
O
LED10
O
LED10
Short sensor display: O
O
●
LED6
LED7
LED8 LED9
O
O
LED10
Pass test display: O
●
●
●
LED6
LED7
LED8 LED9
O
LED10
Sensor status blank unl gets a valid reading
6
O FF
7
●
●
●
●
O
LED1
LED2
LED3
LED4
LED5
8
O FF
NONE Compressor & Cond Fan
NONE
O
O
O
LED6
LED7
LED8 LED9
OFF
O FF
Entry: Display step number & turn ON the Cond fan. Do: Service user to monitor load. Exit: Load o.
N/A
OFF
O FF
®
®
®
®
O
O
LED10
Whirlpool , Maytag , Amana , & IKEA Refrigerators
n 2
DIAGNOSTICS
For Service Serv ice Technician Technician Use Only O nly Step 9
Step Code
Component
O
O
O
O
●
LED1
LED2
LED3
LED4
LED5
O FF
Damper close OFF
11
O
O
O
●
●
Damper
LED1
LED2
LED3
LED4
LED5
heater ON
12
O FF
13
O
O
●
●
●
LED1
LED2
LED3
LED4
LED5
NONE
14
OFF
15
O
●
●
●
●
LED1
LED2
LED3
LED4
LED5
Defrost Heater ON
NONE
16
O FF
17
●
O
O
O
●
LED1
LED2
LED3
LED4
LED5
Evaporator Fan ON
NONE
18
O FF
19
●
O
O
●
●
LED1
LED2
LED3
LED4
LED5
Dispenser light ON
NONE
20
O FF
21
●
O
●
●
●
LED1
LED2
LED3
LED4
LED5
Water Dispenser Valve
NONE
22
O FF
23
●
●
O
●
●
LED1
LED2
LED3
LED4
LED5
RC door switch input
NONE
24
OFF
25
●
●
●
O
●
LED1
LED2
LED3
LED4
LED5
FC door switch input
NONE Ice Paddle
O FF
NONE
®
®
Feedback
Damper Dam per Open Open Entry: Entry: Displa Display y step step number number & open open N/A damper. Do: Service user to monitor the damper posion. Exit: Damper close.
10
26
Acon
®
®
Entry: Display step number & turn on
O FF
N/A
damper heater. Do: Service user to monitor the damper heater. Exit: Load o. OFF
O FF
Entry: Display step number & turn on the heater he ater.. Do: Service user to monitor the load. Exit: Load o.
N/A
OFF
O FF
Entry: Display step number & turn on the EVAP fan. Do: Service user to monitor the load. Exit: Load o.
N/A
OFF
O FF
Entry: Display step number & turn on the dispenser lights. Do: Service user to monitor the load. Exit: Load o.
N/A
OFF
O FF
Entry: Display step number. Do: Press the water paddle to acvate valve and monitor load. Exit: Load o.
NOTE: Water valve will remain on aer paddle release, to exit press key SW2 (Light).
OFF
O FF
Entry: Display step number. Do: Lights will have to be veried on the product. Exit: N/A.
Door Open: Internal RC lights ON. Door Closed: Internal RC lights OFF.
OFF
O FF
Entry: Display step number. Do: Lights will have to be veried on the product. Exit: N/A.
Door Open: Internal FC lights ON. Door Closed: Internal FC lights OFF.
OFF
O FF
Entry: Display step number. Do: User to press ice paddle. Service user to monitor the display feedback. Exit: N/A.
Paddle Pressed:
OFF
O FF
●
O
LED6
LED7
O
O LED8 LED9
O
LED10
NOTE: No water is dispensed in this step.
5
26
n Whirlpool
, Maytag , Amana , & IKEA Refrigerators
DIAGNOSTICS
For Service Se rvice Technician Technician Use Only Step
27
Step Code ●
O
O
LED1
LED2
LED3
●
O
LED4
LED5
28
O FF
29
●
O
●
O
O
LED1
LED2
LED3
LED4
LED5
Component
Acon
Water Paddle
Entry: Display step number. Do: User to press water paddle. Service user to monitor the display feedback. Exit: N/A.
Paddle Pressed:
OFF
O FF
NONE
Feedback
Ice harvest
●
O
O
LED6
LED7
LED8 LED9
1.
Blank = Unl get a valid reading
O
O
O
LED6
LED7
LED8 LED9
O
LED6
LED7
LED8 LED9
●
●
O
●
O
LED1
LED2
LED3
LED4
LED5
Ice maker water ll test
O
LED6
LED7
LED8 LED9
OFF
NONE
O
●
●
LED6
LED7
LED8 LED9
O
●
●
LED6
LED7
LED8 LED9
●
●
●
●
LED6
LED7
LED8 LED9
OFF
O FF
Entry: Display step number. Upon entry to this step, there will be a 3 seconds delay, and then the ice tray will be moved to the home posion. Do: Aer the tray has reached home posion, the "CHANGE SETTING KEY" will start an ice maker ll (only 100 ml +/- 10). Service user to monitor the display feedback. Exit: Clear feedback informaon.
RC Feedback informaon O
O
LED6
LED7
●
O
LED6
LED7
LED10 O
LED10
●
LED10
O
O LED8 LED9
O
LED10
O
O LED8 LED9
O
LED10
Water ll OFF ●
LED6
LED7
OFF
O FF
®
O
Ice tray moving to the home posion
●
®
LED10
Conguraon to start
NOTE: At step entry the water ll cycle default to OFF. Prior entry of this run step 29, make sure the ice tray is empty. Before proceeding with water ll, otherwise, double ll will occur. Make sure to proceed with step 29 aer water ll test to leave tray empty when nishing service. Ice bucket must be in place to run this test.
®
O
Switch faulty or motor (Timeout = 20 seconds)
●
4.
LED10
Ice bucket not full
●
2.
O
Ice bucket full detected
●
1.
LED10
IM harvest cycle is OFF ●
3.
32
O
●
6.
O
IM harvest cycle is ON O
5.
31
O
●
4.
NONE
LED10
RC Feedback informaon
3.
OFF
O
NOTE: No water is dispensed in this step.
2.
30
O
O
O LED8 LED9
O
LED10
Water ll ON
●
●
●
LED6
LED7
LED8 LED9
®
O
O
LED10
Whirlpool , Maytag , Amana , & IKEA Refrigerators
n 2-7
DIAGNOSTICS
For Service Serv ice Technician Technician Use Only O nly Step
33
Step Code
Component
●
O
●
O
●
LED1
LED2
LED3
LED4
LED5
SANKYO Ice maker - Ice tray thermistor
Acon
Feedback
Entry: Display step number. Do: Read the current temperature of the ice maker tray, thermistor and compare this value. This informaon shall be dynamically updated every second. Service user to monitor the display feedback. Exit: Clear feedback informaon.
Open sensor display ●
O
O
LED6
LED7
LED8 LED9
O
O
LED10
Short sensor display O
O
LED6
LED7
●
O LED8 LED9
O
LED10
Pass test display NOTE: For models without twist tray ice maker, the feedback will read as open.
34
OFF
35
●
●
●
●
●
LED1
LED2
LED3
LED4
LED5
NONE Service completed
O
●
●
LED6
LED7
LED8 LED9
●
O
O
LED6
LED7
O FF
Last step in service
N/A
Service Mode Steps For Athena Control
O
O LED8 LED9
System Action
Display Informaon D9
D8
D7
D6
0
□
□
□
□
Start condion
1
□
□
Ƀ
□
Compressor On
2
□
□
□
□
Compressor O
3
□
Ƀ
□
□
Heater On
4
□
□
□
□
Heater O
5
Ƀ
□
□
□
Not Used
6
□
□
□
□
Display Fail Message
□
Ƀ
□
□
Return To Normal OP (Default To Med)
7
Load
The fail informaon is shown withtable. the LEDs turned ON, this will appear in step 6 frombelow the above NOTE: If step 6 shows all LEDs blank means that board drivers and sensors are working correctly.
®
®
®
®
O
LED10
D 6 (MIN POSITION)
During the rst 30 seconds aer power up the product, press TEMP seng buon, unl is located min posion, then hold the refrigerator refriger ator door switch to simulate the door is closed, and at the same me hold press refrigerator TEMP buon for 5 seconds unl the board enters service mode.
Switch Press
LED10
Sensor status blank unl gets a valid reading
OFF
Into service state mode, all temperature LEDs turn on for and turn OFF aer 10 seconds. A user must use the SW1 buon to advance steps into service mode. User shall wait 3 seconds between each keypress to allow the system stabilizaon. All sensors will be tested without required acon from service personnel. This acon is taken aer the heater o. Aer last step press SW1 to exit service mode, user interfac interface e will reset to the last mode and start the power-up state.
O
Replace Water Filter
D7
t s e
D8
d l o C
Ideal
D9
Water Filter Reset Hold 3 sec
SW1
2-8
n Whirlpool
, Maytag , Amana , & IKEA Refrigerators
DIAGNOSTICS
For Service Se rvice Technician Technician Use Only Display Fail Message State Table Display Informaon
LEDs ON (No Blinking) when Illuminated
D9
D8
D7
D6
□
□
Ƀ
□
Main Board (Heater driver or compressor driver)
□
Ƀ
□
□
Refrigerator Sensor
Ƀ
□
□
□
Defrost Sensor
Ƀ
Ƀ
□
□
Refrigerator & Defrost Sensor
□
Ƀ
Ƀ
□
Main Board + Refrigerator Sensor
Ƀ
□
Ƀ
□
Main Board + Defrost Sensor
Ƀ
Ƀ
Ƀ
□
Mulple Failures (Sensors + Drivers)
For Display Model Only: For water lter indicator reset LED test, press and hold TEMP buon for 3 seconds unl the water lter LED blinks to verify LED funcon. For dispenser funcon, use the wiring diagram for reference to validate all connecons and switch operaon.
Sales Demo Mode CUDA 17 IDI & DPLUS Water Filter Reset & Showroom Mode
SHOWROOM Mode Use Case To enter showroom mode 1.
Within 2 minutes aer powerup, press and (RC & FC TEMP keys) forhold 5 seconds.
Reference
System Feedback The system enters in Showroom mode. UI performs "showroom animaon":
Fake normal mode is normal mode with all cooling loads o.. o
• All ve LEDs (RC & FC TEMP LEDs) turn on one by one from le to right and then right to le and keep cycling. (Cycling rate: 1 cycle per second). • Showroom mode does not acvat acvate e sleep mode. • If there is no user acon during 2 minutes of showroom mode, the animaon will stop and then UI behaves (fake) as normal mode. • During the animaon, if the user touches any key, the animaon will stop and UI behaves as a fake normal mode. • During fake normal mode, aer two minutes without user interacon, the animaon will start again to indicate that UI is in showroom mode.
Press (FC TEMP SETTING or RC TEMP SETTING) key in the showroom mode.
The recommended temperature temperature seng (i.e. ) is on. Then UI behaves (fake) as normal mode if the user presses any key again, except that cooling stays o in showroom mode and no temperature seng is saved.
Press (LIGHT) Key in show room
Behavior will be same as normal operaon.
Press (ICE TYPE) key in show room mode.
Ice-type LED changes between crush when the user presses the Ice Type key.
®
®
®
®
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
n 2-9
DIAGNOSTICS
For Service Serv ice Technician Technician Use Only O nly CUDA 17 D Iite & Non Disp Water Filter Reset & Showroom Mode
Replace Water Filter
t s e d l o C
Ideal
Water Filter Reset Hold 3 sec
Showroom Mode Use Case To enter showroom mode
Within 2 minutes aer power-up, toggle (TEMP SETTING) buon ll is on. 2. Hold DOOR SWITCH to simulate door close. 3. Press and hold (TEMP SETTING) for 3 seconds. 1.
System Feedback The system enters into Showroom mode. UI performs "showroom mode": • All four LEDs turns on one by one from top to boom and then boom to top and keep cycling. (Cycling rate: 1 cycle per second)
Press (TE TEM MP SE SETT TTIN ING G) bu buo on n in sh show owrroo oom m mod ode. e.
LEDs stop cycli LED lin ng. Th The e rec ecom omm men ende ded d tem emp per era atur ure e se se ng (i (i..e. ) is on. Then UI behaves (fake) (fake) as normal mode if user presses (TEMP SETTING) buon again, except that cooling stays o in the showroom mode and no temperature seng is saved.
User inacvity for 3 seconds
UI returns to "showroom animaon".
To exit showroom mode
UI exits showroom mode and returns to normal mode with the default seng.
Toggle (TEMP SETTING) buon will is on. 2. Hold DOOR SWITCH to simulate door close. 3. Press and hold (TEMP SETTING) for 3 seconds. 1.
Power interval during showroom mode.
UI returns to Normal mode aer a power reset or power failure.
2-10
n Whirlpool
®
, Maytag®, Amana®, & IKEA® Refrigerators
DIAGNOSTICS
For Service Se rvice Technician Technician Use Only
Notes
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
DIAGNOSTICS
For Service Serv ice Technician Technician Use Only O nly
Notes
n 2-11
2-12
n Whirlpool
®
, Maytag®, Amana®, & IKEA® Refrigerators
COMPONENT TESTING
Section 3: Componentt Testing Componen Testing This secon provides the wiring diagram and component locaon for the “Whirlpool®, Maytag®, Amana®, and IKEA® Refrigerators.” ■
Safety
■
Wiring Diagram
■
Component Locaon
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
COMPONENT TESTING
For Service Serv ice Technician Technician Use Only O nly Safety WARNING
DANGER
Electrical Shock Hazard
Electrical Shock Hazard Disconnect power before servicing.
Only authorized technicians should perform diagnostic voltage measurements.
Replace all parts and panels before operating.
After performing voltage measurements, disconnect power before servicing.
Failure to do so can result in death or electrical shock.
Failure to follow these instructions can result in death or electrical shock.
Voltage Measurement Safety Information When performing live voltage measurements, you must do the following: Verify the controls are in the off position so that the appliance does not start when energized.
Allow enough space to perform the voltage measurements without obstructions.
Keep other people a safe distance away from the appliance to prevent potential injury.
Always use the proper testing equipment.
After voltage measurements, always disconnect power before servicing.
Electronics s IMPORTANT : Electrostatic Discharge (ESD) Sensitive Electronic ESD problems are present everywhere. ESD may damage or weaken the electronic control assembly. The new control assembly may appear to work well after repair is finished, but failure may occur at a later date due to ESD stress.
Use an antistatic wrist strap. Connect wrist strap to green ground connection point or unpainted metal in the appliance -ORTouch your finger repeatedly to a green ground connection point or unpainted metal in the appliance.
Before removing the part from its package, touch the antistatic bag to a green ground connection point or unpainted metal in the appliance.
Avoid touching electronic parts or terminal contacts; handle electronic control assembly by edges only.
When repackaging failed electronic control assembly in antistatic bag, observe above instructions.
n 3-1
3-2
n Whirlpool
®
, Maytag®, Amana®, & IKEA® Refrigerators
COMPONENT TESTING
For Service Se rvice Technician Technician Use Only Wiring Diagram Wiring diagram A for models: WRS321SDHB, WRS321SDHB01, WRS321SDHB02, WRS321SDHV, WRS321SDHV01, WRS321SDHV02, WRS321SDHW, WRS321SDHW01, WRS321SDHW02, WRS321SDHZ, WRS321SDHZ01, WRS321SDHZ02, WRS325SDHB, WRS325SDHB01, WRS325SDHB02, WRS325SDHV, WRS325SDHV01, WRS325SDHV02, WRS325SDHW, WRS325SDHW01, WRS325SDHW02, WRS325SDHZ, WRS325SDHZ01, WRS321SDHB, WRS321SDHB00, WRS321SDHV, WRS321SDHV00, WRS321SDHW, WRS321SDHW00, WRS321SDHZ, WRS321SDHZ00, WRS325SDHB, WRS325SDHB00, WRS325SDHV, WRS325SDHV00, WRS325SDHW, WRS325SDHW00, WRS325SDHZ, WRS325SDHZ00.
CONNECTOR P1
P2
P3 MAIN CONTROL (ACU)
P4 P5 P8
VOLTAGE TEST POINTS THESEUS TO COLOR
FROM
COLOR
P1-1
BK
P1-2
WH
120 VAC Input constant from Power Cord
P1-2
WH
P11-4 4
RD
120 VA VAC Ou Outp tpu ut to to Co Compr pres esso sor/ r/C Con onde dens nser er Fan whe when n coo cooli ling ng
P2-1
YL/RD
P1-1
BK
120 12 0 VAC VAC In Inpu putt FC FC Lig Light ht sw swit itch ch fe feed edba back ck
P2-4
YL
P1-1
BK
120 12 0 VAC VAC In Inpu putt FC FC Lig Light ht sw swit itch ch fe feed edba back ck
P2-6
RD/WH
P1-2
WH
120 VAC Output to Evaporator Fan when cooling
P2-7
BR
P1-2
WH
120 VAC Output Defrost Heater when defrosng
P3-4
V
P1-2
WH
120 VAC Output to Water Valve when water dispensing
P3-5
LB
P1-1
BK
120 VA VAC Inp Input ut FC Doo Doorr swi swittch
P3-6
GY/OR
P1-2
WH
120 VAC Output to Cube Solenoid when dispensing cube
P3-8
BU
P1-2
WH
120 VAC Output to Auger Motor when dispensing ice
P4-1
OR
P4-4
LB
P4-3 GY
SPECIFICATIONS
12.7 VDC Output to User Interface DATA COMMUNICATION
P5-1
GY
P5-2
GY
5 VDC Input RC Thermistor
P5-3
TN
P5-4
TN
5 VDC Input FC Thermistor
P8-1
PK
P8-2
PK
5 VD VDC C In Inpu putt Def Defrros ostt Th Ther ermi mist stor or
P8-7
V
P8-8
RD
12.7 12 .7 VD VDC C Out Outpu putt to to Dis Dispe pens nser er LE LED D
P70
P11
P11-3
P70-7 BU
12 VDC Pulse Damper Stepper Motor coil A +
P70-8 BH
12 VDC Pulse Damper Stepper Motor coil A -
P11-1 YL
12 VDC Pulse Damper Stepper Motor coil B +
P11-2 RD
12 VDC Pulse Damper Stepper Motor coil B -
BR
P11-4
BR
12 VDC Output to damper Heater
VOLTAGE VOLT AGE TEST TES T POINTS MINOTA MINOTAUR UR
H MI
J1
J1-1
LB
J1-4
J1-2 GY
OR
12.7 VDC Output to User Interface DATA COMMUNICATION
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
n 3-3
COMPONENT TESTING
For Service Technician Use Only Wiring diagram A W A T E R2 1 P 2 1 A D P E K V L
L E D D I S P E N S E R
2
1
2
1
T G N Y
I C E P A D E L
P A D D L E H A R N E S S
2
T O T P G V _ N K Y J 3 _ U 4 3 2 1 I
U I
2 1
T O _ D I S V R D P E N S E R _ L E D
T T O O _ J 1 G _ N O G L U D R Y B I 4 3 2 1
2 1
C O M P R E S O R
T O _ C O M P R E S S O R
RD RD WH WH
1 1
2 2
GN/YL
GND L1 L2
T O _ _ C G O RM O P U R N E D S S O R
C O N M D F A N
1
1 2
R E C O R D G N
B K S M O O T H
4
T O _ W I R E _ A S S Y _ F R _ L N R _ 1
RD
WH
T O _ C O N D E N S O R _ F A N
T O _ W I D E T E S T E R 1 2
1 2
1 2
BU
GY GY LB LB
TN RD/WH BR LB WH BKRIBBED GN/YL GN/YL BKSMOOTH BK
GN
WH WH V
2
2
5 6 7 8 9
1 2 3 4 5 6 7 8 9
1
1
2 3
2 3
PK
4 5
4 5 6 7 8 9 1 0 1 1 1 2
PK WH OR GY LB
O _ 3 2 1 W I R E _ W G N L A H / Y B S L S Y _ D O O R _ H V
H
F C L A M P T O L I G H T S O C K W E H T /
T O L I G H T S O C Y K L E T
T N
9 8 7 6 5 4 3 2 1
R W W B D W H H R / H
G G P N N P K / / K Y Y L L
2 1 2 1 2 1
RD
T O _ P 5 _ I M V A L V E
GY GY BU WH YL RD BR BR TN
WH Y L / R D
B B K K
2 1 W G Y H / O R
B B R Y R R D L
R V D
T O P 1 1
5 4 3 2 1 _
P P K K
T O P 8
8 7 6 5 4 3 2 1 _
W B H U
T T G G N N Y Y
9 8 7 6 5 4 3 2 1
T O _ P 7 0
T O P 5
4 3 2 1 _
4 3 2 1
Y L / R D
G B Y L V U / O B R
L G O B Y R
T O _ P 4
8 7 6 5 4 3 2 1
T O _ P 3
R D B Y / L W R H
1 2 3 4
T O P 2
5 6 7 _
T O _ P 1
E R M O T O R
T O _ W I R E _ A S S Y _ F R W G E E B G WW H Y Y Z U N / O L E / H H T / R Y N R _ L L I N 9 8 7 6 5 4 3 2 1 E R
T O _ W I R E _ A S S Y _ E V A P _ H R N
9
8 7 6 5
G G B N N W W U / Y / Y H H L L
T O _ W I R E _ A S S Y _ A U G E R _ M O T O R
4 3 2 1
G W W Y Y Y H H / O L L R
F S C W L I I T G C H H T
M A C I K E E R
N O N C C O M M O N
3 2 1
T O F C
4 3 2 1 _
3 2 1 _
G R N T B W I / E Y N K H _ L A
Y L B _ L B K L I
S S Y _ I M
G H T _ S W
BU TN RD/WH BR LB LB WH GN/YL GN/YL BK BK
6 7 8 9 1 0 1 1 1 2
YL
GY/OR PK PK WH OR GY LB RD V
1
1
BK
2 3 4
2 3 4
WH
5 6 7
5 6 7
8 9 1 0 1 1 1 2 1 3 1 4
8 9 1 0 1 1 1 2 1 3 1 4
R C L I N E R H A R N E S S
BK BU
YL RD BR BR TN TN
BK/WH WH/TN YL R /D
S P L N U
T O _ D A M P E R _ 1 H A R N
B K / W H
B B T T Y R W B B B K K N N L D H U R R 1 0 9 8 7 6 5 4 3 2
T O _ L I G H T _ S W I T C H _ 1
W B H K
4 3 2 1
E R M O T O R
T O D I S P
T O W
1 0 9 8 7 6 5 4 3 2 1
R D
I C E D I S P H A D R I N S P E E S N S S
W E N H S
4 3 2 1
O T O T _ _ W U N I R I T E _ _ R A C S S Y _ R C _ L N R
W H
S P L P H
M
T O D I S P E N S G E N R / Y M B L O U T O R
R
T O _ W I R E _ A S S Y _ WW B R G G D WW B B P N N P L I WH H K K K / N H H R / Y / Y K E H L L R _ F 9 8 7 6 5 4 3 2 1 C
G G NN / Y / Y L L
T O C U B E / C R U S H E D S O L E N O I D
WH WH TN
BK
n Whirlpool
3 4
YL
TN
3-4
_ H V
/ Y L
H
R A T I L O _ _ G F RR O O U N L T Y N _ _ 3 2 1 F T D R
L G O V R D B Y R
T O F A N M O T O R G N W N U H
H E E A V T A E P R 1 1 T O T H O 1 T 1 T D H O R E E W B A D G F R H R T E N O E F D S RR T P O H H S T A T E R G N N U / T T Y F F L U H U H S E S E E R E R M M N A P A W U L B H L
T O D I S P E N S E R M O T O R G N D
T O _ W I R E _ A S S Y _ U N I T _ F R _ 1
GY/OR
V
1
I R E _ A S S Y _ D O O R _ V L
T O 2 1 _ D I S P E N T S O E _ _ W H I E R A E T _ W G A N L E B R S H / Y S
S S D O O ( O P R T I H O E N A A L T ) E R
F A N M O T O R T O F A N M O T O R R D P / W H
M
C S U O B E L / E C NR O U I S D H E D
T O T T _ C O O H _ _ U _ W A F R W N I S _ T R R I S L I E I N E _ S F _ R A _ R _ A _ G _ S S 2 S R 2 O S Y Y _ U N D
GN/YL
T O _ P 5 _ W A T E R V A L V E
1
T O _ W I R E L G O _ V R D B Y R A S S Y 6 5 4 3 2 1 _ F R T _ O L _ 6 5 4 3 2 1 V W
2 1
T O 2 1 _ E V P P A K K P _ S E N S O R
T O F A N M O T O R G N D
B K R I B B E D
3
4
1
I C E M A K E R W A T E R V A L V E
P O W
2
3
2
W A T E R D I S P W A T E R V A L V E
U N I T H A R N E S S
D H S I E P A E T N E S R E
E V A P S E N S O 1 R
F A N ,E V A P ,H T R H A R N E S S
W W H H
A C U
B B K K
R C S E N S O R
Y L
F C S E N S O R
R D
M
W H
D A M P E R C +
B U
M
B K
D A M P E R B +
B K
Y Y L L / R / R DD
S C O W MM O I T N C H N
O
D A M ( P O P E T R I H O E N A A L T ) E R
T O _ L I G H T _ S W I T C 1 H _ 2 1
NC
Y Y L L / R / R D D
W W H H / T / T N N
Y Y L L / / R R D D
T O _ C R B 1 _ 1
T O C R B 1 _ 2
R C L AM P T OP
T O _ C R I S P E R _ B U L B _ 1
T O _ C R B 2 _ 1
T O _ C R B 2 _ 2
R C L A MP M D I 1
W H / T N
Y L / R D
WW HH / T / T NN
T O P _ C R B 3 _ 1
T O P _ C R B 3 _ 2
R C L A MP M D I 2
T O _ C R I S P E R _ B U L B _ 2
T O _ C R I S P E R _ B U L B _ 3
®
, Maytag®, Amana®, & IKEA® Refrigerators
COMPONENT TESTING
For Service Se rvice Technician Technician Use Only Wiring diagram B for models: ASI2575GRB, ASI2575GRB01, ASI2575GRS, ASI2575GRS01, ASI2575GRW, ASI2575GRW01, WRS315SDHB, WRS315SDHB01, WRS315SDHM, WRS315SDHM01, WRS315SDHT, WRS315SDHT01, WRS315SDHW, WRS315SDHW01, WRS311SDHB, WRS311SDHB00, WRS311SDHB01, WRS311SDHM, WRS311SDHM00, WRS311SDHM01, WRS311SDHM02, WRS311SDHT, WRS311SDHT00, WRS311SDHT01, WRS311SDHW, WRS311SDHW00, WRS311SDHW01, WRS311SDHZ, WRS311SDHZ00, WRS311SDHZ01, WRS315SDHB, WRS315SDHB00, WRS315SDHM, WRS315SDHM00, WRS315SDHM02, WRS315SDHT, WRS315SDHT00, WRS315SDHW, WRS315SDHW00, WRS315SDHZ, WRS315SDHZ00, WRS315SDHZ01. VOLTAGE VOLT AGE TEST TES T POINTS ATHENA
CONNECTOR J2
MAIN CONTROL (ACU) JP1
FROM
COLOR
TO
COLOR
J2-1
PK
J2-2
PK
5 VDC VDC In Inpu putt Eva Evapo pora rato torr The Therm rmis isto torr
J2-3
GY
J2-4
GY
5 VDC Input Refrigerator Thermistor
JP1-1
YL
JP1-3
BK
120 VAC input FC Light switch feedback when the door is open
JP1-2
BR
JP1-6
WH
120 VAC Output Defrost Heater when defrosng
JP1-3
BK
JP1-6
WH
120 VAC Input Constant from Power Cord
JP1-4
RD
JP1-6
WH
120 VAC Output to Compressor and Fans when cooling
SPECIFICATIONS
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
COMPONENT TESTING
For Service Technician Use Only Wiring diagram B LIGHTSWITCH NO
FC LINER HARNESS
TO_LIGHT_SWITCH
COMMON
NC
1
1
2
2
3
3
WH LB YL
TO_WIRE_ASSY_ICE_MAKER
ICE MAKER
1
1
2
2
3
3
4
4
WH BK TN GN/YL
DISPENSERMOTOR
TODISPENSERMOTOR
M
WH
CONTROL BOX ATHENA HARNESS
BU
TO_J2_ATHENA
TODISPENSERMOTOR
WH
TOCUBE/CRUSHEDSOLENOID
YL GY/OR
GY/OR 1
1
2
2
WH/TN
WH
WH WH
TOCUBE/CRUSHEDSOLENOID
GN/YL BU
PK
TO_ICE_DISPENSER_AND_LIGHT
TO_WIRE_ASSY_FREEZER_LINER
CUBE/CRUSHED SOLENOID
1
1
2
2
3
3
4
4
5
5
6
6
7
7
YL YL
PK
WH/RD BK BK
BR
1
1
2
2
3
3
4
4
5
5
6
6
7
8
8
9
9
RD BK
WH/TN GN/YL GN/YL BU
YL
TOLIGHTSOCKET
FCLAMP
PK
1
PK
2
WH
GY
3
PK
GY
GN/YL
TODISPENSERMOTORGND
YL
ATHENA BR
7
8
8
9
9
10
10
11
11
12
12
13
13
14
14
TO_RC_CONTROL_BOX
4
PK
RD BK
YL
1
BR
2
BK
3 4
RD
5
YL
6
WH
TO_JP1_ATHENA
TO_WIRE_ASSY_FC_LINER
WH/TN
TOLIGHTSOCKET H H Y Y K L K L W W G G B Y B Y
ICE DISPENSER HARNESS
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
TO_WIRE_ASSY_RC_LINER
EVAPHEATER
TO_DEFROST_HEATER_PH 1
1
1
1
BR
WH
TO_DEFROST_HEATER_NU
1
1
BR
1
1
WH TO_FREEZER_COMPARTMENT PK
1
1
GN/YL GN/YL PK
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
BK BK
FANMOTOR
TO_FAN_MOTOR
M
1
1
2
2
WH WH RD/WH BR
RD/WH WH
WH WH
RCSENSOR
TORCSENSOR
PK GN/YL GN/YL PK BK BK
GY GY
1
1
2
2
BK BK
BK WH RD/WH BR WH WH
TO_WIRE_ASSY_LINER_FC
H H W W
L L Y Y
K K B B
L L Y Y
K K B B
L L Y Y
K K B B
L L Y Y
GN/YL
TO_FAN_MOTOR_GND EVAPSENSOR
RCLINER HARNESS
H H Y Y K L K L W W G G B Y B Y
THERMAL_FUSE_NU
GN/YL
TOHTRGND
TO_CONTROL_BOX_RC
THERMAL_FUSE_PH
TO_EVAP_SENSOR 1
1
2
2
PK PK
FAN,EVAP,HEATER HARNESS C N C OM MO N
NO
TO_RC_SWTICH
1
2
3
4
L L Y / Y / N N G G
L L Y Y H H / / K K N N B B W W G G
H W / D T N K K R D V T B B R 5
6
7
8
L Y B K / B N L G
9
TO_UNIT_COMPARTMENT
TO_FRONT_RAIL_GND
TOWIREASSY-FCLNR,NONI F CLNR,NONIDI,CUDA,LEDSERIE D I,CUDA,LEDSERIES
1
2
3
2
3
4
5
6
7
D E H B B W I R K B
8 L Y / N G
9 H T O
1
2
3
1
2
3
4
1
2
3
4
TO_DOOR_HARNESS_2 TO_DOOR_HARNESS_2
L Y K / N B L B G
O M S K B
T O _C R S I PE R _ BU L B_ 1
D N R / T T U / V B H H W W
TO_DOOR_HARNESS_1 TO_DOOR_HARNESS_1
1
N D D T N / R R V T H W
T O _T O P_ B UL B
D R / N V U B H T W
POWERCORD 2 L D N G 1 L
BKRIBBED
BKSMOOTH
WH/TN V L L Y / Y / N N G G
1
1
2
2
LB
LB
LB
SPL A
TOWATERDISPWATERVALVE
BK BK
BK
SPL B
GY GY
SPL C GY
T O _C R S I PE R _ BU L B_ 2
n 3-5
TN
TOCHASSISGND
WH
1
1
2
2
WH
TOICEMAKERWATERVALVE
L Y / N G
1
TO_DISPENSER_HEATER
H H D R W W
1
1
2
1
2
H W
D R
TOCOMPRESSOR
2
3
2
3
2
1
2
2
3
TO_PADEL TO_WIRE_ASSY_DOOR 1
DISP_GND
2
3
4
1
2
3
4
5
6
TO_SWITCH_PACK_ASSY
Y Y N G T V G TO LEDDISPENSER
DISPENSERHEATER
4
1 1
Y V G
Y N G T
TO_WATER_PADEL
TO_ICE_PADEL
M
COMPRESOR
K B
4
4
TOCONDFAN 1
D R U B Y / L G H B W
Y Y N V G G T
K B B L 1
1 1
2
1
2
2
1
2
2
2
D T R V
LEDDISPENSER RD
CONDFAN I C E P AD E L
W A TE R P A DE L
PADDLE HARNESS UNIT HARNESS
3-6
n
®
®
®
®
Whirlpool , Maytag , Amana , & IKEA Refrigerators
COMPONENT TESTING
For Service Se rvice Technician Technician Use Only Wiring diagram C for models: WRS312SNHB01, WRS312SNHW01, WRS315SNHB, WRS315SNHB01, WRS315SNHM, WRS315SNHM01, WRS315SNHW, WRS315SNHW01, WRSA15SNHN, WRSA15SNHN01, WRSA15SNHZ, WRSA15SNHZ01, WRS312SNHB, WRS312SNHB00, WRS312SNHM, WRS312SNHM00, WRS312SNHM01, WRS312SNHW, WRS312SNHW00, WRS315SNHB, WRS315SNHB00, WRS315SNHM, WRS315SNHM00, WRS315SNHW, WRS315SNHW00, WRSA15SNHN, WRSA15SNHN00, WRSA15SNHZ, WRSA15SNHZ00. VOLTAGE VOLT AGE TEST POINTS ATHENA
CONNECTOR J2
MAIN CONTROL (ACU) JP1
FROM
COLOR
TO
COLOR
J2-1
PK
J2-2
PK
5 VDC VDC In Inpu putt Ev Evap apor ora ato torr The Therm rmis isto torr
J2-3
GY
J2-4
GY
5 VDC Input Refrigerator Thermistor
JP1-1
YL
JP1-3
BK
120 VAC Input FC Light switch feedback when the door is open
JP1-2
BR
JP1-6
WH
120 VAC Output Defrost Heater when defrosng
JP1-3
BK
JP1-6
WH
120 VAC Input constant from Power Cord
JP1-4
RD
JP1-6
WH
120 VAC Output to Compressor and Fans when cooling
SPECIFICATIONS
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
n 3-7
COMPONENT TESTING
For Service Technician Use Only Wiring diagram C CONTROL BOX ATHENA HARNESS
FC LINER HARNESS
TO J2 ATHENA
FC LIGHT SWITCH
TO LIGHT SWITCH 1 NO
COMMON
WH
WH
PK
NC
PK
YL
TO LIGHT SWITCH 2
BR
RD
BK
OPTIONAL
TOWIREASSY-ICEMAKER
YL
1
2
3
1
2
4
5
5
6
6
7
7
8
8
9
9
10
10
11
11
1
PK
2
GY
3
GY
4
YL
1
BR
2
BK
3
RD
4
PK
3
4
PK
WH
PK
ATHENA BR
RD
BK
YL 5
1
1
GN/YL
12
12 WH
2
2
TN
13
13
3
3
BK
14
14
4
4
WH
ICE MAKER
TO RC CONTROL BOX
6
TO JP1 ATHENA
TO WIREASSYLINER FC
TO LIGHT SOCKET 2 H H Y W W G
YL YL
FC LAMP
TO CONTROL BOXRC
Y K G B
K B
L Y
TO WIREASSYLINER RC
2
3
4
5
6
7
8
2
3
4
5
6
7
8
K B
L Y
K B
L Y
H W H G Y G Y W
BK
L Y
1 1
BK
TO LIGHT SOCKET 1
RC SENSOR EVAPHEATER
TODEFROSTHEATERPH 1
1
1
1
GY
GY
BR
WH
TODEFROST HATERNU
TO RC SENSOR
FAN,EVAP,HEATERHARNESS
THERMALFUSE PH
BR
1
1
2
2
BK BK
WH
THERMALFUSE NU
GN/YL
TOFREEZERCOMPARTMENT
TO HTR GND
GN/YL
1
PK
2
2
GN/YL
PK
3
3
BK
4
4
BK
5
5
WH
6
6
WH
RD/WH
7
7
RD/WH
BR
8
8
BR
WH
9
9
WH
PK
1
GN/YL
GN/YL
GN/YL
TO FAN MOTOR GND
FAN MOTOR TOFANMOTORPH
PK
H H W W
L L Y Y
K K B B
L L Y Y
K K B B
L L Y Y
K K B B
L L Y Y
WH
M
RD/WH
WH
TOFANMOTORNU EVAPSENSOR
WH
WH
TOWIREASSYLINER FC
TOEVAPSENSOR 1
1
2
2
C N
PK
1
COMMON
PK
1
NO
TO RC SWTICH H D W R / D R
L Y H H / W W N G
N T
1
2
1
2
3
4
5
6
3
4
5
6
TO TOP BULB
TO CRISPER BULB 1
TO CRISPER BULB 2
K K B B
7
8
9
7
8
9
RC LINER HARNESS
TOUNI T COMPARTMENT TOWIREASSY-FCNONDISP
UNIT HARNESS
D D R R
N T
H D L T E H L Y / Y O B / N N O B W I G G M R S K K B B
POWER CORD
D N G
2 L
BK-RIBBED
1 L
BKSMOOTH
OPTIONAL L Y / N G
TOICE MAKERWATERVALVE TN
1
1
2
2
I CEM AKERW AT ERVALVE
WH WH
L L Y / Y / N N
G G
TO CHASSIS GROUND
D H H R W W
L Y / N G
1
2
1
2
H W
D R
TO COMPRESSOR
1
2
3
4
1
2
3
4
TO COND FAN TO COMPGND
COMPRESSOR
M COND FAN MOTOR
3-8
n Whirlpool
®
, Maytag®, Amana®, & IKEA® Refrigerators
COMPONENT TESTING
For Service Se rvice Technician Technician Use Only
Component Location E
D
C
F
B A
G
A. B. C. D.
Condenser Fan Condenser Freezer Evaporator Auger Ice Dispenser Dispenser
E. Athena Control Control Board F. Front Door Dispenser Unit G. Compressor
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
COMPONENT TESTING
For Service Serv ice Technician Technician Use Only O nly
Notes
n 3-9
3-10
n Whirlpool
®
, Maytag®, Amana®, & IKEA® Refrigerators
COMPONENT ACCESS
Section 4: Access Component This secon provides service parts access, removal, removal, and replacement instrucons for the “Whirlpool®, Maytag®, Amana®, and IKEA® Refrigerators.”
n
Removing the front wheel
n
Accessing the interior of the unit
n
Removing the damper
n
Removing the freezer shelf
Removin Removing g the dispenser n
Accessing the freezer evaporator and components
n
Accessing the dispenser area (removing UI)
n
Accessing the machine compartment
Whirlpool®, Maytag®, Amana®, & IKEA® Refrigerators
COMPONENT ACCESS
Removing the Front Wheel WARNING
3.
Below picture shows the clip and pin. A. Clip and pin A
Electrical Shock Hazard Disconnect power before servicing. Replace all parts and panels before operating. Failure to do so can result in death or electrical shock.
n 4-1
View more...
Comments
