Konka Lcd Tv Kl26as22u Service Manual
Short Description
Descripción: Konka Lcd Tv Kl26as22u Service Manual (09020915437015)...
Description
LCD
TV SERVICE
MANUAL
Modle list KL26AS21U,KL26AS22U,KL32BS22U KL32AS21U,KL32AS23U,KL37AS23U KL37BS22U,KL37AS21U,KL40AS11U KL40AS21U,KL42AS11U,KL42AS23U
KONKA GROUP CO,LTD. Digital Flat Display Division
IMPORTANT SERVICE SAFETY INFORMATION Operating the receiver outside of its cabinet or with its back removed involves a shock hazard. Work on these models should only be performed by those who are thoroughly familiar with precautions necessary when working on high voltage equipment. Exercise care when servicing this chassis with power applied. if carelessly contacted, can cause serious shock or result in damage to the chassis. Maintain interconnecting ground lead connections between chassis, escutcheon, picture tube dag and tuner when operating chassis. When it is necessary to make measurements or tests with AC power applied to the receiver chassis, an Isolation Transformer must be used as a safety precaution and to prevent possible damage to transistors. The Isolation Transformer should be connected between the TV line cord plug and the AC power outlet. It is important to maintain specified values of all components and anywhere else in the received that could cause a rise in operating supply voltages. No changes should be made to the original design of the receiver. Components shown in the shaded areas on the schematic diagram and/or identified by in the replacement parts list should be replaced only with exact factory recommended replacement parts. The use of unauthorized substitute parts man creates may create shock, fire, or other hazards. Before returning the receiver to the user, perform the following safety checks: 1. Inspect all lead dress to make certain that leads are not pinched or that hardware is not lodged between the chassis and other metal parts in the receiver. 2. Replace all protective devices such as non-metallic control knobs, insulating fish papers, cabinet backs, adjustment and compartment covers of shields, isolation resistor-capacitor networks, mechanical insulators etc. 3. To be sure that not shock hazard exists, a check for the presence of leakage current should be made at each exposed metal part having a return path to the chassis (antenna, cabinet metal, screw heads knobs and/or shafts, escutcheon, etc.) in the following manner. Plug the AC line cord directly into a 110V/220V/240V, AC receptacle. (Do not use an Isolation Transformer during these checks.) All checks must be repeated with the AC line cord plug connection reversed. (If necessary, a non-polarized adapter plug must be used only for the purpose of completing these checks.)
PLEASE READ BEFORE ATTEMPTING SERVICE 1. Use an Isolation Transformer when performing any service on this chassis. 2. Never disconnect any leads while receiver is in operation. 3. Disconnect all power before attempting any repairs. 4. Do not short any position of the circuit while the power is on. 5. For safety reasons, replace components any with identical replacement parts (SEE PARTS LIST). 6. Before alignment, warm up the TV for at least 30 minutes. 7. When removing a PCB or related component, after unfastening or changing a wire, be sure to put the wire back in its original position. 8. Inferior silicon grease can damage IC's and transistors. When replacing IC's and transistors, use only specified silicon grease. Remove all old silicon when applying new silicon. 9. Before removing the anode cap, discharge eletricity because it contains high voltage.
A. SPECIFICATION
PAL：M，N；NTSC：M
System : Channel : AIR:
L-VHF:2～6 H-VHF:7～13 UHF :14～69
55.25MHz～83.25MHz 175.25MHz～211.25MHz 471.25MHz～801.25MHz
CABLE: 2～G H～CCC DDD～125
55.25MHz～157.25MHz 163.25MHz～451.25MHz 457.25MHz～801.25MHz
Audio Output Power : Size 26 Power(W) 4W*2
Antenna Impedance
:
32 4 W*2
Item
:
40 5 W*2
42 5 W*2
37
40
42
195
270
270
75Ω
Power Consumption : 340W（Max） Size 26 32 Power 160 180 Consumption(W)
Power Supply
37 5W*2
~110－240V,
50/60Hz
Port List
1
RF
2
Cable
Y/Composite(V2) 、Cb、Cr（SD）
3
Y、Pb、Pr（HD）
4
VGA/RGB
5
VGA Audio Input
6
HDMI Input
7
V1 Input
9
Earphone Audio Output
10
S-Video Input
11
Component Audio Input
B. ADJUSTMENT MANUAL Ⅰ. TEST NOTE 1. Please follow the pointed test steps and choose the right test equipment to conduct
adjustment, otherwise good effect of Unit could not be obtained. The unit should be warmed up for 30 minutes before adjustment and every parameter should be adjusted repeatedly till the optimum value obtained, the pointed voltage value should be ensured during test to get satisfied test result. 2.
Test environment 1) Temperature ： 15°C-35°C 2) Relative Humidity : 45-75% 3) Air pressure : 86-106KPa
3 Test equipments（The following equipment should be calibrated before testing） 1) Computer 1 set 2) Multi-meter (VICTOR VC9801) 1 set 3)VideoSignalGenerator(ChromaModel2227/2327/VG859/SFU) 1 set 4) Color Analyzer (Chroma Model 7120 ) 1 set 5) DDC card (DYNACOLOR, INC D8330) 1 slice 6)TV Video Signal Generator (FLUKE PM54200) 1 set 7)Remote controller with factory keys 1 set 8）AV,VGA, YPbPR/YCbCr,HDMI Signal line etc 1 set
ITEM Equipments
Requirements
Procedure and SPEC
Digital Multimeter
JSK3178-006
1. Connect Power to check if Power LED
Min Board
displays the green light.
Program Menu. M/B 1
Voltage
2. Please refer to appendix 5.1/5.2/5.3 if
confirmation
there is abnormal phenomenon. Update
PC
1. Please refer to appendix 5.6 if there is
NVRAM
Debug Tool
abnormal phenomenon.
2
3
4
5
Update HDMI PC,ALL-11 Debug EEPROM Tool、HDMI Cable
1. Please refer to appendix 5.6 if there is
Update HDCP PC,ALL-11
1. Please refer to appendix 5.6 if there is
abnormal phenomenon.
Debug
Tool
KEY
abnormal phenomenon.
Enter factory menu
1. Enter factory menu : Please MENU
Update NVRAM
1. Enter factory menu，Select “VGA IIC SELECT”
explain
IIC：From VGA Update UOCIII NVRAM
button on the remote control,then Please PRE button per 5 times。
6
TXRX：From VGA Update MCU NVRAM； DDC： From VGA UpdateDDCNVRAM； 7
1.Enter factory menu, Select “RESET”, enactment turn off the power , after be over then factory supply the power again。 （default） Auto color TV Signal Generator AV：interlaced output 1.Enter factory menu, Select “Auto color”, （FLUKE PM54200 PM5418）
PAL
NTSC （NOT：after 10 seconds，factory appear black and “PASS”Auto color adjustment OK；appear
and
Mode,
white signal；
8
YPbPr ： interlaced output
“ FAIL ”
Auto color adjustment be
defeated，then again adjustment。）
COLOR
signal； VGA ： interlaced Color 9
Temp.
adjust white-balance calibrate
1After Color Temp adjustment OK，Can’t” Auto Color” again。
:Color TV Signal Generator Enter black white signal Color Signal Temp and white-balance Generator a.AV
and 1.Enter factory menu, Select “USER RGB”, Adjustment B-R/G/B, chromaticity
calibrate adjust
coordinates of white to fit the12000 Adjustment C-R/G/B, if black calibration.
b.YPbPr: Color HDTV Video Signal Enter black Generator white signal Temp and VG848 white-balance Color Signal calibrate Generator adjust
and 1.Enter factory menu, Select “USER RGB”, Adjustment B-R/G/B, chromaticity
coordinates of white to fit the12000
Adjustment C-R/G/B, if black calibration. HDTV Video Signal Enter black and 1. .Enter factory menu, Select “Color c.VGA Color Generator white signal, Temp and VG848 Enter User menu, Temp”, Select”7500”, chromaticity white-balance Color Signal Select “ Color coordinates of white to fit the7500; calibrate Generator Temp. Select”Memory” chromaticity adjust coordinates of white to fit the12000. 10
TV parameter enactment a.AFC Setup
TV Signal Generator
1. Enter User menu，Select “CHANNEL” ， Setup AFC for “ON”
b.AGC adjust
TV Signal Generator TVEnter 60dB-90dB 1. Press button to display factory “half Color menu on TV and select “RF AGC”, BAR” 、 ”GREY” press volume +/- button to adjust 。 Picture 2. pledge 60dB to 90dB Screen is clear and fluent
11
PC
DDC function
or
Pattern 1024*768@75Hz
； 1. DDC Tester connects with the platform
Picture
then read or writes data in EEPROM.
Generator
examination
2. Affirm DDC2 content
12.
is right or not.
1.Enter User menu, Check if the pictureis
background the snowflake points are come forth，no mode Factory TV Signal or Output PAL Signal Signal is would several minutes enter TV Signal Generator standby state. normal,
TV
check
no
Signal
2. Check Auto Scearch / Management、etc is 13.
14
to 1.Screen is clear and fluent, Audio checks if interlaced output the output is normal。
VIDEO check Video Cable
Set
Y,Cb,Cr(480I/ DVD Component Cable 576I)
Play DVD
720p/1080i Pl
right or not
Play DVD
DVD
Set
DVD
DVD
to
DVD interlaced
t
t（Y Cb C ）
1.Screen is clear and fluent, Audio checks if the output is normal。
15
Y,Pb,Pr
HDTV Receiver
SDTV:
ATSC HDTV Tuner
576P/480P
Component Cable
Play DVD 1.Screen is clear and fluent, Audio checks if
SDTV/HDTV
the output is normal。
(Y,Pr,Pb)
HDTV: 720p/1080i
1.Apiece Mode.Screen is clear and fluent。
PC 16
1.VGA
VGA Cable
INPUT
TV BOX
PC
Mode
Please
refer to appendix 5.5
2. Play TV BOX Screen is clear and fluent, Audio checks if the output is normal。
D-SUB Cable
17
19.
HDMI
SAMSUNG
HDMI Mode Please
DVD-HD948
refer to appendix 5.6
Gdbbk
check
1.Select “SOURC”Eand Select “HDMI” 2.Apiece Mode:Screen is clear and
DVD （ or
fluent, Audio checks if the output is
HDMIofDVD）
normal。
HDMI Cable Gdbbk
18
DVD （ or
1.Select “SOURC”Eand Select “HDMI”
HDCP HDMIofDVD）
20.
check
z
check
HDMI Cabl
Signal Generator output HDMI/HDCP Signal, checks if the
VGA859
output is”PASS”
1.Select “SOURCE”and Select “TV”. Teletext function 19.
FLUKE54200
Output
check
2.Please “Teletext” button on the remote 55dB control.
Teletext Signal
3.Check if the Teletext pictureis normal。 4.Check if the Teletext
function normal.
5..Check if the Teletext
chaos phenomena。
1. plug into Earphone，speaker aphonia，
20
Earphone
Earphone Audio is normal，Press VOL+-
Output
Key Set the sound volume..，Audio checks if
function
Earphone、DVD
TV or play DVD IN the output is normal
check 2. pull out Earphone，speaker Audio is normal.。 PC 、 DVDPattern V or play DVD IN 21.
remote control function check
Generator TV Generator HDTV Pl
1. Check if the apiece mode function Signal
normal。
C. Key IC list Item
P/N
Type
Circuit No.
Qty.
1
19004890
W79E632A40PL-PLCC44-Winbond/#
N001
1
2
19004329
TDA1308-SO8-PHILIP/#
N201
1
3
19006219
HY5DU281622FTP-5-TSOPII-HYNIX/#
N507，N508
2
4
19006110
MST6151DA-LF-PQFP208-MSTAR/#
N504
1
5
19005679
MP1430-SOIC8-MPS/#
N800
1
6
19003437
MP1410ES-LF-SOIC-8-MPS/#
N801
1
8
19005010
AZ1117H-3.3TRE1-SOT223-BCD/#
N803，N806，N805，N809
4
10
19005235
AZ1117H-1.8TR-SOT223-AAC/#
N804，N807
2
11
19005236
AZ1117H-2.5TR-SOT223-AAC/#
N808
1
12
19005582
DA15011H1/N1C00-QFP128-PHILIP/#
N401
1
13
19005532
CS4344-10LD TSSOP-CirrusLogic/#
N500
1
Mstar 6151DA CHASSIS SYSTEM LAYOUT Speaker connector
Sub board
System Power supply POWER MODULE
Digital board IR Key board
Power of Panel LVDS to panel
LCD PANEL
AC input
5
4
3
2
1
1 2 3 4 5
Z101 M3953M
NC C410
0.22uF
C416
110 108
0.22uF
80 79 95 94 96
4 AUIN1_L 4 AUIN1_R 4 AUIN4_L 4 AUIN4_R
7 TV_VOUT_PIN22
R412
NC
TV_VOUT_PIN22R418
100
R407
C411 C428
R420
150nF
C412
R427
39K 100K
0.1uF
10uF/16V
C430 R430
2.2uF/16V R428 C426 4.7nF
8.2K
1K C425 +
+3.3VA R400
4.7K
4.7u/16V C423
3.3nF
NC C431
C422
+5VA
R433
NC
24C16
102 103 97 101
IREF VSC EHTO GNDIF
112 113
PH1LF PH2LF
91 90 38 116
REFAD VGUARD
115
DECDIG
119
XIN
Z400 2 8 7 6 5
NV_SCL NV_SDA
1
R413 R436
27K NC
R409
4.7K
R419
L103
1 2 3 4 5
560nH
R117 47
C403 NC
R443
100p C408
C405
R445
100p C407
R104 100
UOC_A_5V
C401 4.7uF/16V C413
R118
R100 1.2K
1nF
0/NC
R101 10K C101 0.01uF
UOC_A_5V
TV_VOUT_PIN22 TV_HOUT_PIN67 7
0/680
AGC IFVO FMRO
98 86 85
PLLIF
88
R441
390
SIFAGC AGC2SIF
87 83
C418
1uF
AUDOUTSL AUDOUTSR AUDOUTLSL AUDOUTLSR AUDOUTHPL AUDOUTHPR
93 92 69 68 67 66
P00/I2SDI1/O P01/I2SDO1 P02/I2SDO2 P03/I2SCLK P04/I2SWS
23 24 25 26 27
INT0
32
P10/INT1 P11/T0 P12/INT2 P13/T1 P14/RX P15/TX P16/SCL P17/SDA
31 30 3 22 2 1 21 20
P20/TPWM P21/PWM0 P22/PWM1 P23/PWM2 P24/PWM3 P25/PWM4
18 17 16 15 7 6
P30/ADC0 P31/ADC1 P32/ADC2 P33/ADC3
14 13 10 9
R426 R429
C414
10nF
C415
0.1uF
V100 BC847
C419
1uF
R102
1
R410 R411
100 100
47K
V102 BC847
AUDIO_LO 4 AUDIO_RO 4 M_LOUT_PIN60 3 M_ROUT_PIN61 3 HP_LOUT 3 HP_ROUT 3
100 100
C
3
1
R103
1.2K
R105 1.2K +3.3VA
NC
+3.3VA
New edit UOCIII ir cancel R408 R415 R404 R403 R435 R434 R401 R440
R406 3.3K
NC 100 100 100 100 100 100 100
MUTE 3,6 INT 6,7
SAW_SW UOC_READY
NV_SCL NV_SDA
2mm 4 3 2 1
UOC_SCL 5,6 UOC_SDA 5,6
100
R414
3.3K
3.3K
XS400 R416 R432 R425 R424 R423 R422 R421 3.3K
R446
100
R447
R448
100
R449
TO J18
+5VA
6
MSC_READ 6 R431
3.3K
3.3K
3.3K
3.3K
3.3K
3.3K +3.3VA
SIDE_AV_SW 4
3.3K
AGC1
B
hdmi_audio_SW4 UOC_A_5V
N100
24.576MHZ C421 C429 33P
100p C409 NC
HOUT
62
NC
84
33 36 VADC VDDA
125 41 19 39 124 122 120 35
11 29 12 5 126 VDD18 VDDC2 VDDC1 VDDC3 VDDC4
VCC8V SVM FBISO
64 63
100 100 100
15 14 13 12
AGC TU AS SCL SDA NC VCC AFC VT GND IF
VCC WP SCL SDA
XOUT
BCLIN BLKIN
46 45
R437 R438 R439
R442
DECSDEM QSSO
111 89 48
C424 0.1uF N400 1 A0 2 A1 3 A2 4 GND
AUDIO4_INL AUDIO4_INR AUDIO5_INL AUDIO5_INR SSIF VDRA VDRB DECBG
118
B
SECPLL EWD/AVL
106 107 109
0.1uF
47uF/16V
AUDIO2_INL AUDIO2_INR AUDIO3_INL AUDIO3_INR
44 43 42
2
R405
UOCIII
ROUT GOUT BOUT
D100 1N4148
3
76 75 73 72
4 AUIN3_L 4 AUIN3_R 4 AUIN2_LIN 4 AUIN2_RIN
VIFIN1 VIFIN2 SIF1 SIF2
GNDA VSSC
105 104 100 99
CVBSO/PIP
37 127
modified by lenzhi
SVO/CVBSI
VSSC VSSC VSSC VSS_REF VSS_COMB VSSADC
81 UOC_VIFIN1 UOC_VIFIN2 UOC_SIF1 UOC_SIF2
CVBS2/Y2 CVBS3/Y3 CVBS4/Y4 C2/C3 C4
GREF_SDAC1 GREF_SDAC2
74 71 78 70 77
4 VIDE1_IN
UOC_A_5V
60 114 82 47
0.1uF
4 SVIDEO2_YIN_PIN71 4 SVIDEO_YIN_PIN58 4 SVIDEO2_CIN_PIN70 4 SVIDEO_CIN_PIN59
C
V/R2/Pr U/B2/Pb Y/G2/Y YSYNC
CVBSOUT 4
2
0.1uF
65
UOC_SIF2 UOC_SIF1
C433
C402
Y_OUT
D
Z102 M9352M
1n
0
28 8 4 40 61 34
C435
4 VIDEO2_IN
R402
55 54 53
1n C432
Y_OUT
59 58 57 56
YOUT UOUT/INSSW2 VOUT/SWO1
IF_OUT
NC
0.1uF
123 121
pin71→pin78 pin70→pin77
0.1uF
R3/Pr G3/Y B3/Pb INSSW3
UOC_VIFIN2 UOC_VIFIN1
TV_R_PIN85 4 TV_G_PIN86 4 TV_B_PIN87 4
33P
TUNER
15 14 13 12
C105 0.01
1 2 3 4 5 6 7 8 9 10 11
C436
C417
51 50 49 52
VDDA3 VDDA1 VDDP VREFAD VREF_SDAC1 VREF_SDAC2 VREF_SDAC3 VDDA2
Cb
Cb
0.1uF
GNDA GNDA
SV_Y SV_C
4
pin78→pin74
C434
Cr
Cr
128 117
Video2
4
GNDA1 GNDA2 GNDA3
Video1 pin74→pin81 AU1_R pin75→pin79 AU2_L pin79→pin80
VCOMB VP1 VP2 VP3
N401
C406
100p C427 100p C404
+8V D
2.7uH 2.7uH 2.7uH
NC
L401 L400 L402
+1.8VA
R444
+1.8VA
NC
+3.3VA
100p C420
+5VA1
R107 4.7K
L101
C122
R110
470
100
R115 10K
C102 0.01 5V
10uF/16V 0.01 C107
L100
AGC1 UOC_SCL UOC_SDA
1.2K C104 0.01
C109 10u/16V
L102 1uH C103 0.01
IF_OUT
V103 C388
R106 1K
47uH
R109 33 C110 47uF/16V
0.1 C111
R113
C108
R114 100
R116 22K
R111 100
47uH
10u/16V
R108 R112 100
+5VA1
A
A
Mstar semiconductor Co.,Ltd Shanghai Branch 021-68790600*1007 Title
UOC3+MST6151A BOARD Size C Date: 5
4
3
2
Document Number
Rev 1
2.UOC3 Thursday, November 09, 2006 1
Sheet
1
of
8
5 5
8
M4 HOLE
8
4
4
9
5 5
8
9 8
M5 HOLE
4
3 3 2 2 1 1
9
4
9
5 5
8
MARK2 1
MARK3 1
MARK4 1
MARK5 1
MARK6 1
MARK7 1
mark
mark
mark
mark
mark
mark
mark
9 8
mark changed
6 7
9
3 3 2 2 1 1
3 3 2 2 1 1 4
MARK1 1
7
8
4
6
8
M3 HOLE
6 7
5 5
9
7
9
6
8
4
6 7
8
4
M2 HOLE
1
7
5 5
C820 C828 0.01uF 470uF/50V
6
C812 0.1uF
9
Sta_5V 3A
Poweren
4 5 5
M8 HOLE
8
4
3 3 2 2 1 1
9
9 8
4 5 5
9 8
9 8
6 7
4
M7 HOLE
8
7
9
9 8
6
4 5 5
3 3 2 2 1 1
4
6 7
M6 HOLE
7
0.1
6
C804
470uF/25V
6 7
C845
6
3.96mm
3 3 2 2 1 1
D
7
D
CUP_5V
F801
9
6
3A
1 2 3 4 5
4
6 7
4
M1 HOLE
7
F800
6
12VU
xs805 pin1 and pin5 swaped XS805
3 3 2 2 1 1
2
3 3 2 2 1 1
3
6 7
4
7
5
12VU R804 L812 FB1210
STANDBY 6
C889 C897
10K 47uF/16V
L811
1 2 3 4
FB1210 C8A
C8B
C854
470uF/25V
C814
C821
0.22/25V
1nF
N800
C815 10n
R823
BS N/C IN EN SW COMP GND FB
0.22/25V
8 7 6 5
R807
L809
C808 3.3n
390K R800 10K
100K
L801
0.1uF
C
5V for panel
R808 1.5K
C819 0.47uF
C856 470uF/25V
C803
C822
0.22/25V
0.22/25V
1 2 3 4
8 7 6 5
BS N/C IN EN SW COMP GND FB
L804 FB1206 R809
MP1410ES
R806 10K
L810
net standby changed to panel_en
R803 R802 10K
15uH
5V
C809 180p
PANELVCCin
L814
0.1 0.1 0.1 0.1 New edit
C823 0.1uF
C894
FB1206/3A
D804 FM5820
C895
R810 1.5K
47uH
1 2 3 4
C811 0.1
47uH
S S S G
D D D D
12V for panel
8 7 6 5
L813 C855 470uF/25V
C843
C810
10uf/10V
C842
100uF/16V 0.1uF
470uF/16V
12VU
FB1206/3A
PANELVCCin is for Pannel 5V or 3.3V
C806
3
C841
VO
2
C830 0.1uF
C807 0.1uF
C817 0.1uF
C847 47uF/16V C837 0.1uF
C801 0.1uF
+1.8VA N804
5V C829
C857
9435A
0.1uF
GND
C838 0.1uF
C835 0.1uF
0.1uF
C849 47uF/16V
10K
4
RC1117/3.3V
10uf/10V 47uF_E_DNS
N802 R812 3.3K R813
VO
5V
C8D 10uF_E_DNS
12VU 5VD
+5VA
+3.3VA
IN
C853
5V
L803
1
C844 47uF/16V
390K
C8C 470uF/25V
L802
N803
3
C800 3.3n
470uF/25V
C861
C840
470uF/25V
C860
C846
C859
D805 FM5820 C858
47uH
R821 100K
PANEL_EN 6
15uH
+5VA1
C896 0.47F
10K
R824
R801 30K
10uF/16V_E_DNS
N801
C802 10n R805
MP1410ES
10uF/16V_E_DNS
10K
C827 180p
30K
12VU
SET
R807
R801
R808
5.0V
390K
30K
1.5K
3.3V
410K
15K
2K
2
VO
4
1
GND
VO
2
C826 0.1uF
C824 0.1uF
C832 0.1uF
C834 0.1uF
C
C850
RC1117/1.8 47uF/16V
C825 0.1uF
C836 0.1uF
C839 0.1uF
10uf/10V
+8V
PDP9-12V
1
IN
C833
470uF/25V
R811 510
3
L805
D806
47uH C848
8V
47uF/16V
C862 0.1uF
BC847 V801 BC847V801
+5VA : 5V for SYSTEM +3.3VA : 3.3V for UOC +1.8VA : 1.8V for UOC
AVDD、A6V、A9V L824
5V
AVDD、A6V、A9V TC801 470uF
XS809 JST-2mm 1
B
FB1210 C903 0.1uF
B
D3.3V GND
2
L826 FB1210
3 4
TC802 470uF
5 6
+3.3V
5Vsb GND L827
7 R818 1K
Backlight
R822 NC/1K
9
L808 FB/0603 C816 0.1uF
3 2 1
3 C852
1uF/10V
V805 1
R819 4K7 BKLadj 6
BC847
GND
12
Ready
13
/Display
J5 FOR INVETOR
R826 4K7 STANDBY R828
接电源转接板XS803 GND
C818 0.1uF
XS806
C902 0.1uF
11
2
2mm
TC809 470uF
10
R815 10K
cup_5v FB1210
8
4K7 R825
5V
C904 0.1uF
5V
0Ω_LG
6
TC810 C910
V807 BC847_LGNS
L825 FB1210
R829
470R_LGNS
0.1uF 470uF GND
R816
GND R830
4.7K L807 R814 FB/0603
100
C851
3
A
V806 BC847_LGNS
V804 1 R817
2K
BKLon/off
BKLon/off
R831 510
6
R827
470R_LGNS
HV_ON
HV_ON
A
PDP9-12V GND
2
BC847
1uF/10V
0Ω
Title
UOC3+MST6151A BOARD Size A2 Date: 5
4
3
2
Document Number
Rev 1
3.POWER Thursday, November 09, 2006 1
Sheet
2
of
8
5
4
3
2
1
XS201 R211
1 M_LOUT_PIN60 1 M_ROUT_PIN61
R206
R204
47
47
1 2 3 4 5 6
R203 47
47
1 2 3 4 5 6 CN6
D
D
+5VA
C217 0.1
2
+5VA D200 R205 22K
C200
1
3.6V BC847
R209 22K
C218 1nF
1N4148_NS
R215 10K
MUTE_H V202 1,6 MUTE
D201
47uF/16V
R207 330
MUTE_PA V200
R208 1K
C
C213
MUTE_L
+5VA
BC847
R219 10K
1 HP_ROUT
R212 2K R220 47K C208 1nF
C209 22/16V 1nF
C210 0.1
N201 VCC OUTB INBINB+
OUTA INAINA+ GND
TDA1308
+5VA
1 2 3 4
V201
R213 10K
C219 0.1
100mAmax
C214 1nF L201
FB_1KΩ_100mA
C211 0.1 220uF/10V
C205 0.1
C215 C201
R202 22K 47uF/16V
BC847
+5VA C216
R201 22K
60mAmax
L203
FB_1KΩ_100mA
LEFT
L202
FB_1KΩ_100mA
RIGHT
100/16V
C203 470pF
B
C212
C202 0.1
R217 22K 8 7 6 5
C
R210
R218 10K
C206 470pF
R214 10K
B
60mAmax
2K
1 HP_LOUT R216 47K
1 8 7 3 2 4 5
C204 22/16V 1nF
C207 100/16V
XS616 PC_AUDIO_OUT
A
A
Mstar semiconductor Co.,Ltd Shanghai Branch 021-68790600*1007 Title
UOC3+MST6151A BOARD Size A3 Date: 5
4
3
2
Document Number
Rev 1
4.AUDIO Thursday, November 09, 2006
Sheet 1
3
of
8
5
4
3
2
D627
+5VA R663
AUIN3_R 1
1K C638 1u
470p
NC
C614
NC
10K
47K
C652 10uF/16V
100 R632
3
100 C624 0.33u
C620
BAV99
470p
R655
R665
AUIN3_L 1
1K C633 1u
10K
NC
NC
8
7
D622
上
D623
C602 1u
0
2 1
2
R705
1K C604 100
BAV99
2
BAV99
XS607A
3
3
3
47K
R646
R706
47K
22K/nc
75
R621 22K
TV_GIN1
R638 220
1 TV_R_PIN85
22K/nc AUIN4_Lin
C603 1u D630
1
4
R650 D629
2
12 1
22K/nc
100
R624 15K
+5VA
+5VA
+5VA
2
R662
R664
C601
+5VA
D
V603 BC847
1
C653 10uF/16V
R704
BAV99
AUDIO RCA
R313
NEW EDIT.THE SAME TO GUOBIN. 22K/nc Add r705,r706,r703,r704 AUIN4_Rin
1K
BAV99
XS607B
TO MST6151A
HD/TV_RGB_SW 6
100
C654 10uF/16V
V604 BC847
1
1 TV_G_PIN86
R645
R314
1 TV_B_PIN87
R625 15K
75
TV_BIN1
R644 220
0 R315
1
4
R612
R605 22K
R703
R649
3
5
47K
11 5
6
+5VA
RIN1 7 GIN1 7 BIN1 7
PI5V330Q
100
1
3 2
R642 220
+5VA
3
1
TV_RIN1
C635 0.1u
16 4 7 9 12 1 15 8
2
XS604
R623 15K
R654
C605
75
AUIN2_R
R696 C645
R643
VCC D1 D2 D3 D4 SEL /EN GND
3
1
V602 BC847
1 2
2
D
R601 22K
R658
C644
RCA YPBPR/PC RGB INPUT N600 TO MST6151A Pr 2 S1AIN HD_Y 5 S2AIN Pb 11 S3AIN 14 S4AIN TV_RIN1 3 S1BIN TV_GIN1 6 S2BIN TV_BIN1 10 S3BIN 13 S4BIN
AUIN2_L
R617 R602
C625
BAV99 D628
+5VA
10uH C651 10uF/16V
3
C623 0.33u
2
1
L600
100
3
3
R627
2 +5VA
1
YPbPr_AUDIO_IN
75
R322 75
side-AL
R308
R660
R614 22K
75
C612 100
side-composite_flt side-AL_flt side-AR_flt R657 AU_Lin1
22K
1K C608 1u
100
D619
D620
C610
S1AIN S2AIN S3AIN S4AIN S1BIN S2BIN S3BIN S4BIN
1
2
1
C657 0.1u
16 4 7 9 12 1 15 8
VCC D1 D2 D3 D4 SEL /EN GND
VIDEO2_IN 1 AUIN2_LIN 1 AUIN2_RIN 1 R628 100
PI5V330Q
47K
New edit UOCIII
AUIN1_R 1
R639 47K
R600
C606 SVIDEO_YIN_PIN58
R603
C629 0.1uF
100
D614
75
R626
100PF BAV99
S-VIDEO
+5VA
+5VA V606 BC847 R666
R648
75 Pr
C632 0.1uF
R656
D615
15K
5PF
R604 100
C631
75
100PF
220
9
+5VA
2
SVIDEO_CIN_PIN59
1
BAV99
1
1
R641 10uF/16V
75
B
3 22K
R616
2
3
C646
1
3
1 2 3 4
1
1
2
+5VA D624 BAV99
3
3
3
2
1
2
1
2
1
4 2
2
1
2
1
3
D625 BAV99
C642 C627 C643 5PF
TO UOCIII
SIDE_AV_SW 1
XS614
L607 FB/0603 L608 FB/0603 L609 FB/0603 5PF
2 5 11 14 3 6 10 13
+5VA
D626 BAV99
B
R310 R685
11
100 C634 10uF_E Y/VIDEO2 0
BAV99 +5VA
L604 0
22K
N608 V607 BC847
1
R615
C669
10uF/16V
7 HDMI-AUDIO-R 7 HDMI-AUDIO-L Pb
75
1
2
100 0 C665 10uF_E
3
R635 75
15K R698
A
C647
Cb 4 R634
BAV99 +5VA
D642
Cb
3
C664 10uF_E
+5VA
R619 220
Cr 4
2 5 11 14 3 6 10 13
S1AIN S2AIN S3AIN S4AIN S1BIN S2BIN S3BIN S4BIN
VCC D1 D2 D3 D4 SEL /EN GND
C659 0.1u 16 0 4 R678 AUIN4_R 1 0 7 R702 1 edit by wj.R678 andAUIN4_L R702. 9 The same to GB. 12 R677 1 Hdmi_audio_SW 1 100 15 8
PI5V330Q
C670
AUIN4_Rin
R311
100
R647 22K
BAV99 +5VA
V605 BC847
1 2
R607 R661 15K 75
A
+5VA
C648 10uF/16V
0
1
2
+5VA
10uH C663 10uF/16V
+5VA R697
D641
+5VA R611
1
YPBPPrIN
100
75
2
6
C615
3
13
R653
3
D621
3
4
2
1 3 5 7 8 10 12 14
New edit
+5VA
5 6 7
+5VA
XS618
47K
BAV99
2
1
2
BAV99
R636
C609 1u
100 BAV99
R652
47K
100
1K
3
3
3
R667 AU_Rin1
Y/VIDEO2 AUIN2_L AUIN2_R
AUIN1_L 1
1K C607
R651
C
N603
BC847 R613
+5VA
10uH C658 10uF/16V
1 VIDE1_IN
R610
D618
2
+5VA 75
R631
1
BAV99
100
L601
47
AV1_OUT
1
C611 0.1u R637
1
100
AV1_IN
V608
side-AR_flt
1K C619 C622
2 C617 0.1/25V
C662 1u
D617
BAV99
+
C613 10u/25V
side-AL_flt
1
D633
BAV99
3
3
14
D632
BAV99
C661 1u
3
0.1uF
1K
CVBSOUT 1
R606
C618 SVIDEO2_YIN_PIN71
R683 D631
+
C697 330pF
side-AR
9
C636 22u
+5VA 100PF
8
L612 33uH
R609 75
7
+5VA
side-composite_flt
2
C660 0.1u
6
NC
1
C637
side-composite
5
R668
100
100
SVIDEO2_CIN_PIN70 0.1uF C641 D616 100PF BAV99
3
R321 R309
3
10
3
22U
+
7
+
side-luma
4
1 AUDIO_RO
100
R618
3
100
13
R307
2
C630 C639
side-chroma
1
NC
330
8 9 12 11
6 C
R659 RoutO
C616
D2006-9A
AUDIO_LO 1
R608
C600 100
1 2 5 4
22U
C640
XS601
0
XS615
330
2
+5VA R633 Lout0
R622 75
HD_Y
AUIN4_Lin
R640 220
Mstar semiconductor Co.,Ltd Shanghai Branch 021-68790600*1007 Title
UOC3+MST6151A BOARD
R312 Size A2
0
Date: 5
4
3
2
Document Number
Rev 1
5.VIDEO Connector Thursday, November 09, 2006 1
Sheet
4
of
8
5
4
3
XS606
D
16 17
1 2 3 4 5 6 7 8 9 10 11 12 13 1614 1715
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
VGAIN_R
L618 FB/0603 L619 FB/0603 L620 FB/0603 R681 75
VGAIN_G VGAIN_B U5V1
1 +5VA L634 DAT_DDC_VGA FB/0603
C682R682 NC 75
R620
100 C649 473
R629
100 C656 473
R630
100 C621 473
C683 NC
D610 BAV70 2
3
1
RIN0 7 GIN0 7 BIN0 7
C650 102
SOG0 7
C677C676C675 5PF 5PF 5PF
VGA_H_SYNC
L635 CLK_DDC_VGA FB/0603
C655R684 NC 75
2
L617 FB/0603 L621 FB/0603
VGA_V_SYNC
R671 33 R670 33
H_SYNC0
R680 100 R679 100 R674 100
7
V_SYNC0 7
C679
473
C680
473
C678
473
GNDR0 7 GNDG0 7 D
GNDB0 7
C686
U5V1 R686 4.7K
4.7K
24C21
8 7 6 5
VCC WP SCL SDA
3 1
1
BAV99
C687 C688 0.1 0.1 0.1
N604
A0 A1 A2 GND
R694
1 2 3 4
NC
edit by wj.R700 and R701. The same to GB.
R317 NC
6 MCU_RX
MCU_RX
1,6 UOC_SCL
UOC_SCL R688 100 R690 100 R700 100 HDMI-DDC-SCL
DDC_SCL
6 MCU_TX
12 14 15 11
X0 X1 X2 X3
X
13
CLK_DDC_VGA
Y
3
DAT_DDC_VGA U5V1
1 5 2 4
Y0 Y1 Y2 Y3
VCC GND INH VEE
10 9
A B
100 100 R695
New edit MCU_TX
1,6 UOC_SDA
UOC_SDA R689 R691 100 R701 100 HDMI-DDC-SDA
DDC_SDA
R699 100 DDC/HWI2C UOC/MCU
6 DDC/HWI2C 6 UOC/MCU
C
D613
R693 R687 4.7K
DDC_SCL DDC_SDA
BAV99
2
+5VA
D612
1
BAV99
2
5.6V
D636 C667C666 NC NC 5.6V
2
D611 D635
5.6V 5.6V
3
D637D638
3
VGA
16 8 6 7
C684
C685
0.1
0.1
C
New edit
N602 74HC4052
+5VA
+5VA
0.1uF/16V
D601 BAV99
1
2
0.1uF/16V
D609 BAV99
C694
1
2
0.1uF/16V
C692
1
0.1uF
C690
2
+
2
C628 22uF
C696
1
C698
0.1uF/16V
D607 BAV99
D604 BAV99
0.1uF/16V
0.1uF/16V
RXC+ RXC-
R+ RG+ GB+ B-
7 7 7 7 7 7 RXC+ 7 RXC- 7
XS603 for HDMI DDC
3 C693
1
2
1
D602 BAV99
0.1uF/16V
B
4 3 2 1
HDMI-DDC-SDA HDMI-DDC-SCL
0.1uF/16V
1K_Ohm_100mA
2
1
XS603
V679 MMBT3906
2
L679
C691
10 10 10 10 10 10 10 10
COM
HDMI_DDC_5V VD667 5.1V
V680 MMBT3906
R707 22K
1
R306 1K
HDMI_J
C689
D605 BAV99
2
C695
1
+5VA
D606 BAV99
2
HDMI/5V
R302 R301 R320 R300 R318 R319 R303 R304
3
3 3
3 3
3
D608 BAV99
1
20 21 22 23
2
B
HDMI-RX2+ HDMI-RX2HDMI-RX1+ HDMI-RX1HDMI-RX0+ HDMI-RX0HDMI-RXC+ HDMI-RXC-
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
DATA2+ DATA2 SHIELD DATA2DATA1+ DATA1 SHIELD DAT1ADATA0+ DATA0 SHIELD DATA0CLK+ CLK SHIELD CLKGND CEC GND NC GND SCL GND SDA DDC/CEC GND +5V POWER HOT PLUG
3
XS605
R708 22K R676 4.7K R672 R673
100
R692
0
VCC WP SCL SDA
C668
NC NC NC GND
1 2 3 4
0.1uF/16V
24C16
3
FB/0603 L636
3
N601
8 7 6 5
100
FB/0603 L637
D634
R669 R675 NC
4.7K
D603 HDMI_SCL
1 B
MMBT3904 A
2 E 23
HDMI_SDA
2
1
2
BAV99L
1
V609
SOT
C 3
BAV99L
HDMI_SCL 7 HDMI_SDA 7
HDMI_DDC_5V
A
R305 1K
HMDI_CTRL
HDMI_CTRL
4
Mstar semiconductor Co.,Ltd Shanghai Branch 021-68790600*1007 Title Size A2 Date: 5
4
3
2
UOC3+MST6151A BOARD 6.Vga_Dvi Connector
Document Number
Friday, November 10, 2006 1
Sheet
5
of
Rev 1 8
5
4
3
2
1
CUP_5V
1 2 3 4
XTAL1
20
XTAL2
10
RESET
100
STANDBY MUTE RSTn R026 100 R027 100
2 STANDBY 1,3 MUTE 5 DDC/HWI2C 4 HD/TV_RGB_SW 5 UOC/MCU 5 HDMI_CTRL 1 MSC_READ
MSC_READ
14 15 16 17
INT0/P3.2 INT1/P3.3 T0/P3.4 T1/P3.5
2 3 4 5 6 7 8 9
P1.0 P1.1 P1.2 P1.3 P1.4 P1.5 P1.6 P1.7
22
CUP_5V C
P4.1
R007
R006
4 3 2 1
R009 XS612 COM
NC
C
RST_MST 7
R029 4.7K
PANEL_EN
7 PWMOUT0
R017
33
R018
33
R019
33 150
R016
LED_R
4 3 2 1 CUP_5V
PWMOUT0
470 WRZ 7 RDZ 7 BKLadj 2
CUP_5V
XS617 COM
R021 4.7K
R23 R22
4.7K HV_ON
2
BKLon/off
2
4.7K
R020
LED_Gout
N002 24C16
VCC WP SCL SDA
R014 4.7K
R015
PANEL_EN 2
LED_Rout
A0 A1 A2 GND
2.0mm
R008 4.7K
MCU_TX 5 MCU_RX 5
edit by wj.The same to GB. 8 7 6 5
1 2 3 4 5 6 7 8
CUP_5V
CUP_5V
1 2 3 4
L002 FB/0603 L003 FB/0603 L004 FB/0603 L005 FB/0603 L006 FB/0603 L007 FB/0603 L008 FB/0603
UOC_READY 1 UOC_SDA 1,5 UOC_SCL 1,5 XS613
5PF 5PF 5PF 5PF 5PF 5PF 5PF
CUP_5V
C004 104
BUD[0..3] 7
C016C017C018C019C020C021C022
SCL5 SDA5
BUD0 BUD1 BUD2 BUD3
LED_G1 SCL_MST1 SDA_MST1
edit by wj. The same to GB
R011 4.7K
D
ALE 7
KEY0 KEY1 KEY2 KEY3 KEY4 KEY5 KEY6
R028 4.7K
R010 4.7K
4 3 2 1 4 3 2 1 MBU0 MBU1 MBU2 MBU3 ALE UOC_READY UOC_SDA UOC_SCL
43 42 41 40 39 38 37 36 1 24 25 26 27 28 29 30 31 23 19 18 32 33 13 11
34
100
P4.3
INT
P0.0 P0.1 P0.2 P0.3 P0.4 P0.5 P0.6 P0.7 P4.2 P2.0 P2.1 P2.2 P2.3 P2.4 P2.5 P2.6 P2.7 P4.0 P3.7/RD P3.6/WR PSEN ALE/P P3.1/TXD P3.0/RXD
RP004 4.7K
4.7K
8 7 6 5 8 7 6 5
4.7K IR1
RP003 4.7K
5 6 7 8 5 6 7 8
21
8 7 6 5
8 7 6 5
EA/VP
RP002
J6 FOR KEY
4.7K
35
VSS
1 2 3 4
C002 10P R003 NC C003 10P
R005 4.7K
1,7 INT
Z001 22.1184MHZ
CUP_5V
4.7K
N001 W79E632
RP006 RP005
R004 4.7K
10K
D001 4148
CUP_5V
CUP_5V RP001
12
D
104
R001
C014 47U/16V
44
R002 8K2
L001 FB
VCC
reset pulse Minimum 100us, active low
C001
1 2 3 4 1 2 3 4
C013 10u/16V
0
B
B
C005 22P
CUP_5V
CUP_5V
XS611
C015 47U/16V
C006 104
5 IR_IN
R025 470R
CUP_5V
3 1 V001 BC847
3
GND
LEDR 2 LEDG 1
2
R024 10k LED_Rout
4
R023
SIP5A_2mm
3
470R
LED_Gout
R022 10k
1 V002 BC847
A
2
A
Mstar semiconductor Co.,Ltd Shanghai Branch 021-68790600*1007 Title
UOC3+MST6151A BOARD Size A3 Date: 5
4
3
2
Document Number
Rev 1
7.Mcu Thursday, November 09, 2006
Sheet 1
6
of
8
5
4
AVDD_DVI
+3.3V
2
VDDP +3.3AVDD
4PIN,10PIN
FB0805
C865
0.1uF
0.1uF
pin66,pin162,pin182
FB0805
C550 47uF/16V
C867
C868
0.1uF
0.1uF
0.1uF
AVDD_PLL
C869 C551 47uF/16V
0.1uF
r o f DL L D V P A _ 3 D . D 3A V +
L823 C585
C564
0.1uF
FB0805/NC
10uF/10V D
47uF/16V
0.1uF
VDDC
0.1uF
204PIN
C559
C880 C881 C882 C883 C884 C885 C886 C891
100uF/16V
0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF C556 47uF/16V
3
VIN
1
ADJ
0.1uF
H_SYNC0 V_SYNC0 BIN0 GNDB0 SOG0 GIN0 GNDG0 RIN0 GNDR0 100
C532 0.047u
R513 100 0 R515 R519 100 R518 100 R511 100 R512 100
GND_BIN1 BIN1_PIN28 GND_GIN1 C534 0.047u GIN1_PIN30 C533 0.047u SOG GND_RIN1 C536 0.047u RIN1_PIN33
100
R517 R516
C531 0.047u
C535 0.047u 100 C537 0.047u
C538
0.1u
C539
0.1u
#HRST
R524 R525
33 #INT #ALE #RDZ #WRZ #BUD0 #BUD1 #BUD2 #BUD3
C540 NC
NC RST_MST
R526
33
RP501 33
33
PWMOUT0
6 PWMOUT0
RP500
5 6 7 8 5 6 7 8
#HRST
4 3 2 1 4 3 2 1
#INT #ALE #RDZ #WRZ #BUD0 #BUD1 #BUD2 #BUD3
27 28 29 30 31 32 33 36 37 38 39 40
BIN0M BIN0 GIN0M GIN0 SOGIN0 RIN0M RIN0 HSYNC0 VSYNC0 RMID REFP REFM
41 42 43 44 45 46 47 48 51 52 53 54 55 56 57 58 59 60 61 77
VI_DATA[8] VI_DATA[9] VI_DATA[10] VI_DATA[11] VI_DATA[12] VI_DATA[13] VI_DATA[14] VI_DATA[15] GPIO[5]/VHS GPIO[4]/VCLK2 VI_CK VI_DATA[0] VI_DATA[1] VI_DATA[2] VI_DATA[3] VI_DATA[4] VI_DATA[5] VI_DATA[6] VI_DATA[7] GPIO[2]/VVS
67 68 69 70 71 72 73 74 75
HWRESET INT ALE RDZ WRZ DBUS[0] DBUS[1] DBUS[2] DBUS[3]
200 201 62 158
C541
76 78
0.1u C542 22P
6 BUD[0..3]
HSYNC1 VSYNC1 BIN1 BIN1M SOGIN1 GIN1 GIN1M RIN1 RIN1M
202 R535 NC
Z501 14.318MHz
203
1
C560 47uF/16V
VOUT VOUT TAB
2 5 4
C557
C878
47uF/16V
10uF/10V
VDDC R541 R501 R540 R500
VDDC VDDC VDDC VDDC VDDC VDDC VDDC
PWM0 PWM1 VCTRL BYPASS GPIO[3]/VDE GPIO[1]/FIELD XOUT XIN
2
TAB
4
0 10 0 NC
N811
D3.3V C558
C879
47uF/16V
10uF/10V
C595 47uF/16V
+2.5V
3
VIN
VOUT
2
1
ADJ
TAB
4
C594
C518
47uF/16V
0.1uF
AIC1117-2.5
AUWS AUSCK AUSD AUMCK
+5VA
199 198 197 196 193 192 191 190 189 188
R563
N500
NC NC LHS LVS R7 R6 R5 R4 R3 R2
63 79 131 156 173 185 195
109 AVDD_PLL2
12
49 VDDC
AVDD_PLL
86 102 113 125 139 154
MST61510A(208Pin)
ADJ
+2.5V
VOUT
RP511
LVB0M/R1 LVB0P/R0 LVB1M LVB1P LVB2M LVB2P LVBCKM LVBCKP LVB3M LVB3P LVA0M LVA0P LVA1M LVA1P LVA2M LVA2P LVACKM LVACKP LVA3M, LVA3P
187 186 181 180 179 178 177 176 175 174 171 170 169 168 167 166 165 164 161 160
DQS[0] MDATA[0] MDATA[1] MDATA[2] MDATA[3] MDATA[4] MDATA[5] MDATA[6] MDATA[7] MDATA[8] MDATA[9] MDATA[10] MDATA[11] MDATA[12] MDATA[13] MDATA[14] MDATA[15] DQS[1] DQM[0] DQM[1] DQS[2] MDATA[16] MDATA[17] MDATA[18] MDATA[19] MDATA[20] MDATA[21] MDATA[22] MDATA[23] MDATA[24] MDATA[25] MDATA[26] MDATA[27] MDATA[28] MDATA[29] MDATA[30] MDATA[31] DQS[3] MADR[11] MADR[10] MADR[9] MADR[8] MADR[7] MADR[6] MADR[5] MADR[4] MADR[3] MADR[2] MADR[1] MADR[0]
153 152 151 150 149 148 147 146 145 144 143 142 141 138 137 136 135 134 133 101 100 99 98 97 96 95 94 93 92 91 90 89 88 85 84 83 82 81 130 129 128 127 124 123 122 121 120 119 118 117
WEZ CASZ RASZ BADR[0] BADR[1]
116 115 112 111 110
MCLK MCLKZ MCLKE MVREF
107 106 105 104
5 6 7 8 5 6 7 8 5 6 7 8 5 6 7 8 5 6 7 8 DQS0U MDATA0 MDATA1 MDATA2 MDATA3 MDATA4 MDATA5 MDATA6 MDATA7 MDATA8 MDATA9 MDATA10 MDATA11 MDATA12 MDATA13 MDATA14 MDATA15 DQS1U DQM0U DQM1U DQS2U MDATA16 MDATA17 MDATA18 MDATA19 MDATA20 MDATA21 MDATA22 MDATA23 MDATA24 MDATA25 MDATA26 MDATA27 MDATA28 MDATA29 MDATA30 MDATA31 DQS3U A11 A10 A9 A8 A7 A6 A5 A4 A3 A2 A1 A0 WE CAS RAS SBA0 SBA1
5 6 7 8
4 3 2 1 4 3 2 1 4 3 2 1 4 3 2 1 4 3 2 1
RP512 0 RP513 0 RP514 0 RP515 0
RXO0RXO0+ RXO1RXO1+ RXO2RXO2+ RXOCRXOC+ RXO3RXO3+ RXE0RXE0+ RXE1RXE1+ RXE2RXE2+ RXECRXEC+ RXE3RXE3+
AUSD
1
AOUTR
SDIN
AUSCK
2
AUWS
3
LRCK
AUMCK
4
MCLK
R549 HDMI-AUDIO-R
10
470 10uF/16V
SCLK
C
22K/NC C503
AOUTL
7
C502 R554
R550
CS4344
VA
AVDDPLL2
VIN
9
L508 0603
VDDM VDDM VDDM VDDM VDDM VDDM
VDDP VDDP VDDP
66 162 182
204 AVDD_MPLL
4 10
C507 0.1uF
AZ1117-2.5
R562
HDMI-AUDIO-R
4
3.9n NC
270K
22K/NC
+5VA R564 22K/NC
C505
R551 HDMI-AUDIO-L
L500 600(4.5X3.2)
10uF/16V
HDMI-AUDIO-L
470 C504
R552
R553 NC
+5VA
4
R565 3.9n
270K
0
22K/NC
modified for HDMI audio part
C509 10uF/16V MDATA[0..31] MDATA0 MDATA1 MDATA2 MDATA3 MDATA4 MDATA5 MDATA6 MDATA7 MDATA8 MDATA9 MDATA10 MDATA11 MDATA12 MDATA13 MDATA14 MDATA15 MDATA16 MDATA17 MDATA18 MDATA19 MDATA20 MDATA21 MDATA22 MDATA23 MDATA24 MDATA25 MDATA26 MDATA27 MDATA28 MDATA29 MDATA30 MDATA31
A[0..11] 8
MDATA[0..31] 8
B
+3.3V R530 NC
R531 0
2 4 6 8 10 12 14 16 18 20 22 24 26 28 30
RXE0RXE0+ RXE1RXE1+
RXECRXEC+ RXE3RXE3+ WE 8 CAS 8 RAS 8 SBA0 8 SBA1 8 RP502 4 3 2 1
10R
DQS0
DQS1U R505
10R
DQS1
DQS2U R507
10R
DQS2
DQS3U R504
10R
DQS3
DQM0U R502 R508 DQM1U R503 R509
10R 10R 10R 10R
DQS1 8 DQS2 8 DQS3 8 DQM0 DQM1 DQM2 DQM3
RXO3+ RXO3RXOC+ RXOCRXO2+ RXO2RXO1+ RXO1RXO0+ RXO0-
1 3 5 7 9 11 13 15 17 19 21 23 25 27 29
8 8 8 8
Double LVDS Panel
PANEL_VCC PANELVCCin L509 FB/0805
R533 0
C545 0.1
R534 NC +3.3V
MCLK+ 8 MCLK- 8 CKE 8
MVDD25
DQS0 8
DQM0 DQM1 DQM2 DQM3
C544 0.1
R532 0/nc MCLK+ MCLKCKE
DQS0U R506
XS501 LVDS CON
RXE2RXE2+
33
MCLK+ C527 R529
1 7 13 16 35 50 64 65 80 87 103 108 114 126 132 140 155 157 159 163 172 183 184 194 205 206
C543 22P
10uF/10V C590 47uF/16V
+1.8V
N808
3
GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND
4.7K 470 470 470
VGA interface and YPBPR swaped
18 19 20 21 22 23 24 25 26
+3.3AVDD
PANELVCCin net modified
H_SYNC0 V_SYNC0 BIN0 GNDB0 SOG0 GIN0 GNDG0 RIN0 GNDR0
REXT DVI_R+ DVI_RDVI_G+ DVI_GDVI_B+ DVI_BDVI_CK+ DVI_CKDDCD_DA DDCD_CK
C552 47uF/16V
AZ1117-1.8/TO263
VDD_MPLL VDDP
AVDD_DVI AVDD_DVI
11 207 208 2 3 5 6 8 9 14 15
5 R+ 5 R5 G+ 5 G5 B+ 5 B5 RXC+ 5 RXC5 HDMI_SDA 5 HDMI_SCL
R514
N504
17 34
R510 390 1%
AVDD_ADC AVDD_ADC
C
L515 CBW321611V121B 2 1
D3.3V C870
N807
+3.3V
C588
0.1uF
4
FILT+
C562 47uF/16V
0.1uF
TAB
6
0.1uF
ADJ
AZ1117-3.3
C888 C586
1
C506
FB0805
2
10uF/16V
L822
VOUT
C553 47uF/16V
pin63,pin79,pin131,pin49,pin156, pin173,pin185,pin195
FB0805
VIN
VQ
0.1uF
+1.8V WHY NOT2.5V?
3
C511
0.1uF
C877
+3.3AVDD
N806
5VD
C876
AVDD_DVI
R520 R521 R522 R523
4
10uF/16V
r o f D D V A A 3 D . D 3A V +
C887 C561 47uF/16V
AVDDA
A
2
TAB
GND
0.1uF
C875
MVDD25
E C A F R E T N I P u
VOUT
ADJ
5
0.1uF
C874
AVDD_DVI
INT ALE RDZ WRZ BUD0 BUD1 BUD2 BUD3
VIN
1
C508
C873
VDDC AVDD_PLL
1,6 INT 6 ALE 6 RDZ 6 WRZ
3
AZ1117-3.3/NC
VDD_MPLL
A r oL L f P V_ M 3 . D 3V D +
pin17,pin34
FB0805
6 RST_MST
C501
10uF/10V
+3.3V
5VD
B
+3.3V
C589 47uF/16V
0.1uF/16V
0.1uF
C872
L820
4 RIN1 1 TV_HOUT_PIN67 1 TV_VOUT_PIN22
C548 47uF/16V
8
C587
+3.3V
4 GIN1
L516 CBW321611V121B 2 1
N809
pin86, pin102,pin113,pin125,pin139,pin154
FB0805
AVDDA
4 BIN1
D3.3V C863
C510
+3.3AVDD
5 H_SYNC0 5 V_SYNC0 5 BIN0 5 GNDB0 5 SOG0 5 GIN0 5 GNDG0 5 RIN0 5 GNDR0
4
0.1uF/16V
L819
0.1uF
47uF/16V
T U P N I A G V T U P N I r P b P Y
TAB
C871 C554 47uF/16V
C555
L821
ADJ
8 . 1 c c V
pin12
FB0805
r o f VD C 8 . D 1 V
L818
VOUT
1
5VD
C563 47uF/16V
MVDD25
VIN
2
AZ1117-3.3
D
+2.5V
3
pin109
M D D V r o f ) R D D ( D D V M 5 . 2 +
+3.3AVDD
C866
FB0805
+3.3V
N805
C893 47uF/16V L817
r o f 3 g . o 3a l c c n V a
r o f DV I D V D A _ 3 D . D 3A V +
C549 47uF/16V
C864
L816
2 rL L o f P _ VD D 3 . V 3 A
r o f VP 3 . D 3V D +
L815
AVDDPLL2
1
5VD
r o f l 3 a . t 3g i c c i V d
+3.3AVDD
3
R528 1K
150
NC
MCLKMVREF R527 1.2K
C530 NC
C528 0.1U
Title
UOC3+MST6151A BOARD
C529 0.01U
Size A2 Date:
5
4
3
2
Document Number
Rev 1
8.Mst6151A Thursday, November 09, 2006 1
Sheet
7
of
8
A
5
4
3
2
1
D
D
+2.5V_DMQ
+2.5V_DMC N507
尽量靠近DDRAM和MST6151中间
7 7 7 7
CAS RAS SBA0 SBA1
CAS RAS SBA0 SBA1
MCLK+ MCLK-
7 MCLK+ 7 MCLK7 WE 7 CKE
WE CKE
7 7 7 7
DQM0 DQM1 DQM2 DQM3
DQM0 DQM1 DQM2 DQM3
7 7 7 7
DQS0 DQS1 DQS2 DQS3
MDATA0 MDATA1 MDATA2 MDATA3
5 6 7 8
MDATA4 MDATA5 MDATA6 MDATA7
RP505 5 6 7 8
7 A[0..11]
4 3 2 1 RP10X4 4 3 2 1
RP10X4 尽量靠近DDRAM和MST6151中间 DQS0 DQM0 WE CAS
DQS0 DQS1 DQS2 DQS3
RAS SBA0 SBA1 A10
A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 A11
C
RP503
A0 A1 A2 A3
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33
MVDD DQ0 VDDQ DQ1 DQ2 VSSQ DQ3 DQ4 VDDQ DQ5 DQ6 VSSQ DQ7 NC VDDQ LDQS NC MVDD NC LDM WE CAS RAS CS NC BA0 BA1 A10/AP A0 A1 A2 A3 MVDD
DDR_128Mb_TSOP66 VSS DQ15 VSSQ DQ14 DQ13 VDDQ DQ12 DQ11 VSSQ DQ10 DQ9 VDDQ DQ8 NC VSSQ UDQS NC VREF VSS UDM CLK CLK CKE NC NC A11 A9 A8 A7 A6 A5 A4 VSS
尽量靠近DDRAM和MST6151中间 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34
1RP10X4MDATA8 MDATA9 2 MDATA10 3 MDATA11 4
8 7 6 5
L510 +2.5V_DMC
+2.5V
C578 0.1U
RP504 MDATA12 1RP10X4 MDATA13 2 MDATA14 3 MDATA15 4
8 7 6 5
L512
C575 0.1U
C574 0.1U
+2.5V_DMQ
GND
RP506 尽量靠近DDRAM和MST6151中间 C568 0.1U
DQS1
+1.25VRF +1.25VRF
C569 0.1U
C580 0.1U
+2.5V_DMQ DQM1 MCLKMCLK+
C581 0.1U
CKE A11 A9 A8
C565 0.1U
C572 0.1U
C567 0.1U
C582 0.1U
B
C571 0.1U
C584 47uF/16V
GND
C576 0.1U
C566 0.1U
GND
C577 0.1U
GND C
A7 A6 A5 A4
+2.5V_DMQ R539 1K
+1.25VRF +1.25VRF
2M X 16bit X 4BK
R538
+2.5V_DMQ
+2.5V_DMC
C570 0.1U
+2.5V_DMC
1K MDATA0 MDATA1 MDATA2 MDATA3 MDATA4 MDATA5 MDATA6 MDATA7 MDATA8 MDATA9 MDATA10 MDATA11 MDATA12 MDATA13 MDATA14 MDATA15 MDATA16 MDATA17 MDATA18 MDATA19 MDATA20 MDATA21 MDATA22 MDATA23 MDATA24 MDATA25 MDATA26 MDATA27 MDATA28 MDATA29 MDATA30 MDATA31
C583 47uF/16V
C579 0.1U
C573 0.01U
GND MDATA[0..31] 7
N508 尽量靠近DDRAM和MST6151中间 RP507 5 4 6 3 7 2 8 1 RP10X4 RP509 MDATA28 5 4 MDATA29 6 3 MDATA30 7 2 MDATA31 8 1 RP10X4 尽量靠近DDRAM和MST6151中间 MDATA24 MDATA25 MDATA26 MDATA27
DQS3 DQM3 WE CAS RAS SBA0 SBA1 A10 A0 A1 A2 A3
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33
MVDD DQ0 VDDQ DQ1 DQ2 VSSQ DQ3 DQ4 VDDQ DQ5 DQ6 VSSQ DQ7 NC VDDQ LDQS NC MVDD NC LDM WE CAS RAS CS NC BA0 BA1 A10/AP A0 A1 A2 A3 MVDD
DDR_128Mb_TSOP66 VSS DQ15 VSSQ DQ14 DQ13 VDDQ DQ12 DQ11 VSSQ DQ10 DQ9 VDDQ DQ8 NC VSSQ UDQS NC VREF VSS UDM CLK CLK CKE NC NC A11 A9 A8 A7 A6 A5 A4 VSS
尽量靠近DDRAM和MST6151中间 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34
MDATA16 1RP10X4 MDATA17 2 MDATA18 3 MDATA19 4
8 7 6 5 RP508
MDATA20 1RP10X4 MDATA21 2 MDATA22 3 MDATA23 4
8 7 6 5
RP510 尽量靠近DDRAM和MST6151中间 DQS2
+1.25VRF +1.25VRF
B
DQM2 MCLKMCLK+ CKE A11 A9 A8 A7 A6 A5 A4
2M X 16bit X 4BK 8x16-2.5V HYNIX HY5DU281622ET-5-200MHz
A
A
Title
UOC3+MST6151A BOARD Size C Date: 5
4
3
2
Document Number
Rev 1
Ddram Thursday, November 09, 2006
Sheet 1
8
of
8
(1.33:1) CAM350 PRO V 7.0 : Fri Dec 22 17:32:12 2006 - (Untitled)
PDF 文件以 "PDF 制作工厂" 试用版创建
Àÿ http://www.fineprint.com
(1.33:1) CAM350 PRO V 7.0 : Fri Dec 22 17:36:17 2006 - (Untitled)
PDF 文件以 "PDF 制作工厂" 试用版创建
ÿÿ http://www.fineprint.com
View more...
Comments
