Icom IC-M502 Service Manual
December 10, 2017 | Author: Yayok S. Anggoro | Category: N/A
Short Description
Download Icom IC-M502 Service Manual...
Description
SERVICE MANUAL
VHF MARINE TRANSCEIVER
iM502
INTRODUCTION
DANGER
This service manual describes the latest service information for the IC-M502 VHF MARINE TRANSCEIVER at the time of publication
NEVER connect the transceiver to an AC outlet or to a DC power supply that uses more than 16 V. This will ruin the transceiver.
To upgrade quality, any electrical or mechanical parts and internal circuits are subject to change without notice or obligation.
DO NOT expose the transceiver to rain, snow or any liquids. DO NOT reverse the polarities of the power supply when connecting the transceiver. DO NOT apply an RF signal of more than 20 dBm (100 mW) to the antenna connector. This could damage the transceIer’s front end.
ORDERING PARTS
REPAIR NOTES
Be sure to include the following four points when ordering replacement parts:
1. Make sure a problem is internal before disassembling the transceiver. 2. DO NOT open the transceiver until the transceiver is disconnected from its power source. 3. DO NOT force any of the variable components. Turn them slowly and smoothly. 4. DO NOT short any circuits or electronic parts. An insulated tuning tool MUST be used for all adjustments. 5. DO NOT keep power ON for a long time when the transceiver is defective. 6. DO NOT transmit power into a signal generator or a sweep generator. 7. ALWAYS connect a 40 dB to 50 dB attenuator between the transceiver and a deviation meter or spectrum analyzer when using such test equipment. 8. READ the instructions of test equipment thoroughly before connecting equipment to the transceiver.
1. 2. 3. 4.
10-digit order numbers Component part number and name Equipment model name and unit name Quantity required
1110003200
S.IC
8810006050
Screw Icom screw E7 IC-M502
TA31136FN
IC-M502
MAIN UNIT 15 pieces CHASSIS
10 pieces
Addresses are provided on the inside back cover for your convenience.
TABLE OF CONTENTS SECTION 1 SECTION 2
SPECIFICATIONS INSIDE VIEWS
2-1
IC-M502 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 1
2-2
HM-127 (OPTIONAL UNIT) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 2
SECTION 3
DISASSEMBLY INSTRUCTION
SECTION 4
CIRCUIT DESCRIPTION
4-1
RECEIVER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 1
4-2
TRANSMITTER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 2
4-3
PLL CIRCUIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 3
4-4
DSC CIRCUIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 4
4-5
POWER SUPPLY CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 4
4-6
LOGIC CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 4
4-7
PORT ALLOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 4
SECTION 5
ADJUSTMENT PROCEDURES
5-1
PREPARATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 1
5-2
PLL ADJUSTMENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 2
5-3
TRANSMITTER ADJUSTMENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 3
5-4
RECEIVER ADJUSTMENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 4
SECTION 6
PARTS LIST
SECTION 7
MECHANICAL PARTS
7-1
IC-M502 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 1
7-2
HM-126 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 3
7-3
HM-127 (OPTIONAL UNIT) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 3
SECTION 8
SEMI-CONDUCTOR INFORMATION
SECTION 9
BOARD LAYOUTS
9-1
VOL UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 - 1
9-2
DIAL UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 - 1
9-3
SQL UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 - 1
9-4
LOGIC UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 - 2
9-5
MAIN UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 - 4
9-6
CTRL UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 - 6
9-7
PWR-CORD UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 - 6
9-8
HM-126 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 - 6
9-9
HM-127 (OPTIONAL UNIT) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 - 6
SECTION 10
BLOCK DIAGRAM
SECTION 11
VOLTAGE DIAGRAM
11 - 1 LOGIC UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 - 1 11 - 2 MAIN UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 - 2 11 - 3 HM-127 (OPTIONAL UNIT) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 - 4 11 - 4 HM-126 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 - 5
SECTION 1
SPECIFICATIONS
‘ GENERAL • Frequency coverage
: 156.025–157.425 MHz (Tx) 156.050–163.275 MHz (Rx)
• Mode
: 16K0G3E (FM) 16K0G2E (DSC)
• Usable channels
: All international and USA channels
• Power supply requirement
: 13.8 V DC (negative ground)
• Usable temperature range
: –20˚C to +60˚C (–4 ˚F to +140˚F)
• Frequency stability
: ±10 ppm (–20˚C to +60˚C; –4 ˚F to +140˚F)
• Current drain (at 13.8 V DC)
: Transmit Receive
• Antenna connector
: SO-239 (50 Ω)
• Dimensions (projections not included)
: 165(W)×110(H)×109.4(D) mm 61⁄2(W) ✕ 411⁄32(H) ✕ 45⁄16(D) in
• Weight
: 1130 g (2 lb 8 oz)
at 25 W max. audio
6.5 A 1.2 A
‘ TRANSMITTER • Output power (at 13.8 V DC)
: High Low
25 W 1W
• Modulation
: Variable reactance frequency modulation
• Maximum frequency deviation
: ±5.0 kHz
• Spurious emissions
: 70 dBc
• Adjacent channel power
: 70 dB
• Residual modulation
: 40 dB
• Audio harmonic distortion
: Less than 10% at 60% deviation
• Audio frequency response
: +1 dB to –3 dB of 6 dB octave from 300 Hz to 2500 Hz
• Microphone impedance
: 600 Ω
‘ RECEIVER • Receive system
: Double conversion superheterodyne system
• Intermediate frequencies
: 1st 2nd
• Sensitivity
: 0.32 µV (–117 dBm) at 12 dB SINAD
21.7 MHz 450 kHz
• Squelch sensitivity
: 0.32 µV at threshhold
• Adjacent channel selectivity
: 75 dB
• Spurious response
: 75 dB
• Intermodulation rejection ratio
: 75 dB
• Hum and noise
: 40 dB
• Audio output power (at 13.8 V DC)
: 3.5 W typical at 10% distortion with an 4 Ω load
• Audio frequency responce
: +1 dB to –3 dB of –6 dB octave from 300 Hz to 3000 Hz
Specifications are measured in accordance with TIA/EIA-603
All stated specifications are subject to change without notice or obligation.
1-1
‘ VHF MARINE CHANNEL LIST Channel No. USA INT CAN
157.050
156.050 160.700
156.150
160.750
156.150
156.150
23A
156.200
160.800
24
24
156.200
156.200
25
25
156.250
160.850
26
05A
156.250
156.250
06
156.300
156.300
156.350
160.950
07A
156.350
156.350
61
03
03
04 04A 05 06 07 08
08
08
156.400
156.400
09
09
09
156.450
156.450
10
10
10
156.500
156.500
11
11
11
156.550
156.550
12
12
156.600
156.600
13*
13
13*
156.650
156.650
14
14
14
156.700
156.700
1
157.050
156.100
02
03A
12
21A
156.050 02
07A
Frequency (MHz) Transmit Receive
160.650
01
01A
06
Channel No. USA INT CAN
156.050
01
05A
Frequency (MHz) Receive Transmit
1
21A
Channel No. USA INT CAN 73
73
161.700
74
74
74
156.725
156.725
157.100
77*1
77
77*1
156.875
156.875
23
157.150
161.750
156.925
161.525
157.150
157.150
156.925
156.925
24
157.200
161.800
156.975
161.575
25
157.250
161.850
156.975
156.975
26
26
157.300
161.900
157.025
161.625
27
27
27
157.350
161.950
157.025
157.025
28
28
28
157.400
162.000
157.075
161.675
60
60
156.025
160.625
157.075
157.075
156.075
160.675
157.125
161.725
156.075
156.075
82A
157.125
157.125
156.125
160.725
156.125
156.125
83A
156.175
160.775
84
156.175
156.175
84A
64
156.225
160.825
85
64A
156.225
156.225
85A
23
61A
61A 62
62A 63 63A 64 64A
78 78A 79
80A 81
82A 83
160.875
86
16
16
16
156.800
156.800
65A 65A 65A
156.275
156.275
86A
17
17*
156.850
156.850
66
156.325
160.925
87
156.900
161.500
66A 66A 66A*
156.325
156.325
87A
156.900
156.900
67*1
67
67
156.375
156.375
88
156.950
161.550
68
68
68
156.425
156.425
88A
19A
156.950
156.950
69
156.475
156.475
20*
157.000
161.600
70*
70*
70*
156.525
156.525
157.000
157.000
71
71
71
156.575
156.575
157.050
161.650
72
72
72
156.625
156.625
18 18A
18A 19
19A 20
20
1
20A 21
21
69 2
69 2
2
81A 82
156.275
1
80A
81A
65
17*
79A 80
156.750
1
78A
79A
156.750
1
156.675
157.100
15*
1
156.675
157.100
15*
1
73
22A
22 22A
15*
1
Frequency (MHz) Receive Transmit
84 85 86
83
157.175
161.775
83A
157.175
157.175
84
157.225
161.825
157.225
157.225
157.275
161.875
157.275
157.275
157.325
161.925
157.325
157.325
157.375
161.975
157.375
157.375
157.425
162.025
157.425
157.425
85 86
87
87
88
88
*1 Low power only, *2 Receive only NOTE: Simplex channels 3, 21, 23, 61, 64, 81, 82 and 83 CANNOT be lawfully used by the general public in USA waters.
Weather channel
Frequency (MHz) Transmit Receive
Weather channel
Frequency (MHz) Transmit Receive
WX01
Receive only
162.550
WX06
Receive only
162.500
WX02
Receive only
162.400
WX07
Receive only
162.525
WX03
Receive only
162.475
WX08
Receive only
161.650
WX04
Receive only
162.425
WX09
Receive only
161.775
WX05
Receive only
162.450
WX10
Receive only
163.275
1-2
SECTION 2
INSIDE VIEWS
2-1 IC-M502 • MAIN UNIT
AF power amplifier (IC14: LA4425A)
PLL IC (IC2: µPD3140GS)
VCO circuit
Reference oscillator (X2: CR-659 21.25 MHz)
Drive amplifier (Q12: 2SC2954)
1st IF filter (FI1, FI2: FL-310)
Power module* (IC3: SC-1302)
2nd IF filter (FI3: ALFY450E)
1st mixer* (Q3: 3SK166)
FM IF IC (IC1: TA31136FN) Main MPU (IC16: MB90F583BPFV-G)
Reset IC (IC15: S-80928ANMP)
System clock X3: DMX-26S 36.768 kHz, X4: CR-610 7.9872 MHz * Located under side of the point
• LOGIC UNIT
SUB MPU (IC1: µPD789405AGK-A30-9EU)
System clock (X1: CSTCC4.91MG 4.91 MHz)
DIAL UNIT
LCD driver (IC2: HD66712SA03FS)
SQL UNIT
Speaker
VOL UNIT
2-1
2-2 HM-127 (OPTIONAL UNIT) • TOP VIEW
LCD (DS1: A0119)
• BOTTOM VIEW
System clock (X1: CSTCC4.91MG) CPU (IC1: µPD789405AGK-A30-9EU) Data buffer circuit
Dimmer circuit
Reset IC (IC7: S-80928ANMP)
8V regulator (IC6: TA7808F)
5V regulator (IC5: TA78L05F)
Volume IC (IC3: M62429FP) AF/MIC switch (IC9: TC4W53FU) AF amplifier (IC2: TA7368F)
MIC amplifier (IC4: NJM2125F)
2-2
SECTION 3
DISASSEMBLY INSTRUCTION
CAUTION: DISCONNECT the DC power cable from the transceiver before performing any work on the transceiver. Otherwise, there is danger of electric shock and/or equipment damage. • Opening the transceiver case
• Remove the MAIN unit
q Unscrew 6 screws A, and remove the front unit. w Unscrew 6 screws B, and remove the rear panel.
q Unscrew 4 screws E from the shielding plate, then lift up the shielding plate.
A
E
B
• Removing the LOGIC unit q Unsolder 2 point C. w Disconnect microphone connector from J1 and SQL/DIAL connector from J3. e Unscrew 5 screws D, and remove the LOGIC unit.
D
w Remove the 2 clips F. e Disconnect microphone connector from J7 and CTRL connector from J3 and EX-SP connector from J8 and EX-GPS connector from J2. r Unsolder 10 point G. t Unscrew 5 screws H, and remove the MAIN unit.
D
J1
H
D
H
J3
C C
D
G H G
J2
D
J3 J7
H
J8
3-1
G F H G F
SECTION 4
CIRCUIT DESCRIPTION The signals from the RF circuit are mixed with the VCO signals at the 1st mixer circuit (Q3) to produce a 21.7 MHz 1st IF signal.
4-1 RECEIVER CIRCUITS 4-1-1 ANTENNA SWITCHING CIRCUIT The antenna switching circuit functions as a low-pass filter while receiving and as resonator circuit while transmitting. The circuit does not allow transmit signals to enter receiver circuits.
The 1st IF signal is applied to a pair of crystal filters (FI1, FI2) to suppress out-of-band signals and is then amplified at the IF amplifier (Q4). The amplified signal is applied to the 2nd mixer circuit (IC1).
Received signals enter the MAIN unit from the antenna connector and pass through the low-pass filter (L23–L25, C134, C136–C139). The signals are then applied to the RF circuit via the antenna switching circuit (D17, L26, L27, C141–C143).
4-1-4 2ND IF AND DEMODULATOR CIRCUITS The 2nd mixer circuit converts the 1st IF signal into a 2nd IF signal. A double superheterodyne system (which converts receive signals twice) improves the image rejection ratio and obtains stable receiver gain.
4-1-2 RF CIRCUIT The RF circuit amplifies signals within the range of frequency coverage and filters out-of-band signals.
The FM IF IC (IC1) contains the 2nd local oscillator, 2nd mixer, limiter amplifier, quadrature detector, and noise detector circuits, etc.
The signals from the antenna switching circuit pass through a tunable bandpass filter (D1, L1, C2–C4) where the object signals are led to the RF amplifier circuit (Q2).
The 1st IF signal from Q4 is applied to the 2nd mixer section of IC1 (pin 16), and is mixed with a 21.25 MHz 2nd LO signal generated at the PLL circuit using the reference frequency (21.25 MHz) to produce a 450 kHz 2nd IF signal.
The amplified signals at Q2 are applied to the 3-stage tunable bandpass filter (D2–D4, D34–D36, L2–L4, C13, C14, L33, C16–C18, C20–C24) to suppress unwanted signals and improve the selectivity. The signals are then applied to the 1st mixer circuit.
The 2nd IF signal from IC1 (pin 3) is passed through the ceramic filter (FI3), where unwanted signals are suppressed, and is then applied to the 2nd IF (limiter) amplifier in IC1 (pin 5). The signal is applied to the FM detector section in IC1 for demodulation into AF signals.
D1–D4, D34–D36 employ varactor diodes, that are controlled by the PLL lock voltage, to track the band pass filters.
The FM detector circuit employs a quadrature detection method (linear phase detection), which uses a ceramic discriminator (X1) for phase delay to obtain a non-adjusting circuit. The detected signal from IC1 (pin 9) is applied to the AF circuit.
4-1-3 1ST MIXER AND 1ST IF CIRCUITS The 1st mixer circuit converts the received signal into a fixed frequency of the 1st IF signal with a 1st LO (VCO output) frequency. By changing the 1st LO frequency, only the desired frequency will pass through a pair of crystal filters at the next stage of the mixer.
• 2nd IF and demodulator circuits
2nd IF filter 450 kHz (21.25 MHz)
FI3 Squelch level adjustment pot
8
7
5
3
2
17
16
PLL IC IC2
Noise detector
Active filter
X2 21.25 MHz
Mixer RSSI
Limiter amp. FM detector
IC1 TA31136FN 9
10
11
14
16
1st IF (21.7 MHz) from Q4
AF signal "DEMOD" "SQLI" signal to the DC amplifier (IC20, pin 1) X1 R8V
4-1
The amplified signals are applied to the IDC amplifier (IC13a, pin 2) via the analog switch (IC12, pins 9, 8 and pins 4, 3) and are passed through the splatter filter (IC13b) to suppress unwanted 3 kHz or higher signals. The filtered signals are then applied to the modulation circuit.
4-1-5 AF AMPLIFIER CIRCUIT The AF amplifier circuit amplifies the detected signals to drive a speaker. The AF circuit includes an AF mute circuit for the squelch. AF signals from IC1 (pin 9) are passed through the analog switch (IC12, pins 10, 11), and are applied to the de-emphasis circuit (R118, C182). The de-emphasis circuit is an integrated circuit with frequency characteristic of –6 dB/octave.
4-2-2 MODULATION CIRCUIT The modulation circuit modulates the VCO oscillating signal (RF signal) using the microphone audio signals.
The integrated signals are applied to the active filters (Q24, Q25). Q24 functions as a high-pass filter to suppress unwanted lower noise signals and Q25 functions as a lowpass filter to suppress higher noise signals.
Audio signals from the splatter filter (IC13b) pass through the frequency deviation adjustment pot (R172) and are then applied to the modulation circuit (D8) to change the reactance of D8, and modulate the oscillated signal at the TXVCO (Q7).
The filtered signals are passed through the [VOLUME] control, and are then applied to the AF power amplifier (IC14, pin 1). The output signal from IC14 (pin 4) drives the internal (external) speaker.
4-2-3 DRIVE AMPLIFIER CIRCUIT The drive amplifier circuit amplifies the VCO oscillating signal to a level needed at the power amplifier.
4-1-6 SQUELCH CIRCUIT A squelch circuit cuts out AF signals when no RF signals are received. By detecting noise components in the AF signals, the squelch circuit switches the AF mute switch.
The VCO output is buffer-amplified by Q9 and Q10, and is then applied to the Tx/Rx switch (D12). The transmit signal from the Tx/Rx switch is amplified to the pre-drive (Q11) and drive (Q12) amplifiers to obtain an approximate 200 mW signal level. The amplified signal is then applied to the RF power amplifier (IC3).
A portion of the AF signals from the FM IF IC (IC1, pin 9) pass through the squelch adjustment pot (R33), and are then applied to the active filter section (IC1, pin 8). The active filter section amplifies and filters noise components. The filtered signals are applied to the noise detector section and output from pin 14 as the “SQLI” signal. The “SQLI” signal is amplified at the DC amplifier (IC20) and applied to the CPU (IC16, pin 39) as the “SQL” signal. The CPU analyzes the noise condition and outputs the “RMUTM”, “RMUTS” signals to toggle the AF mute switches (Q26, Q27).
4-2-4 POWER AMPLIFIER CIRCUIT The power amplifier circuit amplifies the driver signal to an output power level. IC3 is a power module which has amplification output capabilities of about 35 W with 300 mW input. The output from IC3 (pin 4) is passed through the antenna switching circuit (D16) and is then applied to the antenna connector via the low-pass filter.
4-2 TRANSMITTER CIRCUITS 4-2-1 MICROPHONE AMPLIFIER CIRCUIT
4-2-5 APC CIRCUIT
The microphone amplifier circuit amplifies audio signals with +6 dB/octave pre-emphasis from the microphone to a level needed at the modulation circuit.
The APC circuit stabilizes transmit output power. The RF output signal from the power amplifier (IC3) is detected at the power detector circuit (D14, D15, L21) and is then applied to one of the differential amplifier inputs (Q16, pin 5) via the High/Low control circuit (R84, Q17). The applied voltage controls the differential amplifier output (Q16, pin 2) and the bias voltage control (Q14). Thus the APC circuit maintains a constant output power.
The AF signals from the microphone are amplified at the microphone amplifier (IC11a) via the analog switch (IC10, pins 11, 10). A capacitor (C214) and resistor (R147) are connected to the amplifier to obtain the pre-emphasis characteristics.
• APC circuit RF signal from PLL
L21
Q12 Drive amp.
Power module IC3
to antenna VCC
T8
D14
D15
RF detector circuit Q18
Q14
/TMUT
Q16
R84
Q15
Q17 HI/LO
APC control circuit
4-2
"TXDET" signal to the CPU
The pulse-type signal is converted into DC voltage (lock voltage) at the loop filter (R252–R254, C292–C294), and is then applied to varactor diodes (D6, D7) of the TX-VCO to stabilize the oscillated frequency.
4-3 PLL CIRCUITS 4-3-1 GENERAL The PLL circuit provides stable oscillation of the transmit frequency and receive 1st LO frequency. The PLL circuit compares the phase of the divided VCO frequency to the reference frequency. The PLL output frequency is controlled by a crystal oscillator and the divided ratio of the programmable divider.
4-3-3 RX LOOP The generated signal at the RX-VCO (Q8, D9, D10) enters the PLL IC (IC2, pin 19) and is divided at the programmable divider section and is then applied to the phase detector section.
IC2 is a dual PLL IC which controls both VCO circuits for Tx and Rx, and contains a prescaler, programmable counter, programmable divider phase detector, charge pomp and etc.
The phase detector compares the input signal with a reference frequency, and then outputs the out-of-phase signal (pulse-type signal) from pin 13.
The PLL circuit, using a one chip PLL IC (IC2), directly generates the transmit frequency and receive 1st IF frequency with VCOs. The PLL sets the divided ratio based on serial data from the CPU and compares the phases of VCO signals with the reference oscillator frequency. The PLL IC detects the out-of-step phase and output from pins 8 and 13 for Tx and Rx, respectively. The reference frequency (21.25 MHz) is oscillated at X2.
The pulse-type signal is converted into DC voltage (lock voltage) at the loop filter (R255–R257, C295, C296), and is then applied to varactor diodes (D9, D10) of the RX-VCO to stabilize the oscillated frequency. The lock voltage is also used for the receiver circuit for the bandpass filter center frequency. The lock voltage from the loop filter is amplified at the buffer-amplifier (Q6) and then applied to the RF circuit.
4-3-2 TX LOOP The generated signal at the TX-VCO (Q7, D6–D8) enters the PLL IC (IC2, pin 2) and is divided at the programmable divider section and is then applied to the phase detector section.
4-3-4 VCO CIRCUIT The VCO outputs from TX-VCO (Q7) and RX-VCO (Q8) are amplified at the buffer amplifiers (Q9 and Q10), and are then sent to the Tx/Rx switch (D11, D12). The receive LO signal is applied to the 1st mixer circuit (Q3) through a low-pass filter, and the transmit signal is applied to the pre-drive amplifier (Q11). A portion of the VCO output is reapplied to the PLL IC (IC2, pin 2 or pin 13) via the buffer amplifier (Q5).
The phase detector compares the input signal with a reference frequency, and then outputs the out-of-phase signal (pulse-type signal) from pin 8.
• PLL circuit
Buffer
RX-VCO
Q10 Q8, D9, D10
D11 to 1st mixer circuit
Buffer D12 to transmitter circuit Q9 Buffer
TX-VCO
Q5 Loop filter
Q7, D6–D8
Loop filter
IC2 (PLL IC) 8
Phase detector
16
Programmable divider
Programmable counter
Prescaler
2
X2 21.25 MHz
21.25 MHz signal to the FM IF IC
3 4 5
Shift register/ data latch
17 13
Phase detector
Programmable counter
4-3
Prescaler
19
PSTB CK DATA
4-4 DSC CIRCUITS (DSC UNIT)
4-6-2 LOGIC UNIT
4-4-1 DSC ENCODE CIRCUIT
• CPU IC1 is an 8 bit single chip micro-computer and contains LCD driver, serial I/O, timer, A/D converter, programmable I/O, ROM and RAM.
The DSC signal created at CPU (IC16), is passed through the buffer amplifier (Q33) and applied to the analog switch (IC12, pin 1). The analog switch (IC12) is a modulation switch that switches between microphone audio signal and DSC signal.
• SYSTEM CLOCK CIRCUIT X1 is a ceramic oscillator and oscillates a 4.91 MHz system clock for the CPU (IC1).
4-4-2 DSC DECODE CIRCUT
• LCD DRIVER IC2 is a LCD driver for a dot matrix LCD.
The AF signals from FM IF IC (IC1, pin 9) are filtered at the bandpass filter (IC4) with +18 dB/octave characteristics. IC4b functions as a low-pass filter to suppress unwanted higher noise signals and IC4a functions as a high-pass filter to suppress lower noise signals. The filtered signals are converted analog signals into digital signals at DSC decoder IC (IC5), and are then applied to the CPU (IC16) after shaping waveform at IC6.
• DIMMER CIRCUIT CPU (IC1) and Q2, Q3, Q8 are dimmer circuit and control the LCD backlight (LED). • CONTRAST CIRCUIT CPU (IC1) and Q1, Q4 are contrast circuit and control the 8 step display contrast.
4-5 POWER SUPPLY CIRCUITS 4-5-1 VOLTAGE LINE (MAIN UNIT)
4-7 PORT ALLOCATIONS
LINE
DESCRIPTION
HV
The voltage from the connected DC power supply.
Pin number
HVS
Same voltage as the HV line which is passed through the [PWR] switch (LOGIC unit; S1).
LRESET, Output ports for the LCD driver (IC2) 27, 28, 29, 30 E, RW, RS control signals.
VCC
Same voltage as the HVS line which is passed through the power controller (RL1).
31–38
DB7– DB0
I/O port for the LCD driver (IC2) control signals.
8V
Common 8 V converted from the VCC line at the 8V regulator circuit (IC8).
42
SCAN
Input port for the [SCAN] key.
43
CHWX
Input port for the [CH/WX] key.
+5V
Common 5 V converted from the 8V line at the +5V regulator circuit (IC9).
44
CH16
Input port for the [16/9] key.
Transmit 8 V controlled by the T8 control circuit (Q20, Q21) using the SEND signal from CPU.
46
SQLV
Input port for the squelch volume level.
T8
47
KEYM
Input port from the microphone (HM126) for remote control signal
51, 52
DIALA, DIALB
Input ports for the [CHANNEL].
54
SRXD
Outputs communication data for main CPU (MAIN unit; IC16).
55
STXD
Input port for the communication data from main CPU (MIAN unit; IC16).
R8
4-7-1 SUB CPU (LOGIC unit; IC1)
Receive 8 V controlled by the R8 control circuit (Q22, Q23) using the RCV signal from CPU. The controlled voltage is applied to the receiver circuits.
4-6 LOGIC CIRCUITS
58–60
4-6-1 MAIN UNIT • MPU IC16 is a 16 bit multifunction micro-computer and contains FLASH memory, serial I/O, timer, A/D converter, D/A converter, programmable I/O, ROM and RAM. • SYSTEM CLOCK CIRCUIT X3, X4 are crystal oscillators and oscillate 7.9872 MHz and 32.768 kHz system clocks for the MPU (IC16) respectively. • RESET CIRCUIT IC15 is a reset IC. When turn power ON, IC15 outputs a reset signal (“LOW” pulse) to MPU (IC16, pin 75).
4-4
Description
CONTSEG3– Output port for the LCD contrast. CONTSEG1
61
DTRS
62
IC
63
DSC
64
HL
75–77
DIM3– DIM1
78–80
• LOW BATTERY DETECTOR VCC voltage is divided by R204, R205 and is applied to the low battery detector section in the MPU (IC16, pin 42).
Port name
Input port for the [DISTRESS] key. Input port for the [LO/DX] key. Input port for the [DSC/ENT] key. Input port for the [HI/LO] key. Output LCD backlight control signal for the dimmer circuit (Q2, Q3, Q8).
CONDOT3– Output port for the LCD contrast. CONDOT1
4-7-2 MAIN CPU (MAIN unit; IC16) Pin number
1
Port name
Description
STRU
Outputs control signal to the analog switch (IC12) for passing through the optional VOICE SCRAMBLER unit (UT98 or UT-112). Outputs ON/OFF control signal for the optional VOICE SCRAMBLER unit (UT-98 or UT-112).
2
SCON
3
Outputs strobe signals for the optional OPSTB VOICE SCRAMBLER unit UT-98 or UT-112.
Pin number
Port name
Description
20
CLTX
Output port for the cloning data to the buffer (MAIN unit; Q37).
23
ECK
Outputs clock signal for EEPROM (IC17).
24
EDA
Outputs serial data signal for EEPROM (IC17).
27
Outputs select signal to the analog MICDSC switch (IC12) for the microphone audio signal or DSC signal.
30
DSC
D/A output port for the ATIS/DSC encode signal to the buffer amplifier (Q33).
39
SQL
Input port from the FM IF IC (IC1) for the squelch operation.
42
LBAT
Input port for the connected power supply voltage detection (low battery indicator).
44
TXDET
Input port for the “TX” indicator from the power detector circuit (D14, D15).
45
DSDEC
Input port for the ATIS/DSC decode signal.
46
UNLK
10
Outputs select signal for the speaker of main microphone (HM-126) to the MMUTE analog switch (IC10) while intercom operation.
60
PTT
61
HANG
11
Outputs select signal for the speaker of optional remote microphone (HMSMUTE 127) to the analog switch (IC10) while intercom operation.
Input port for the microphone hanger detection signal. Low : Microphone on hook
62
OPTIN
Input port for the optional unit connection detection.
66
RCV
Outputs the R8 regulator (Q22, Q23) control signal. Low : While receiving
4
PSTB
Outputs strobe signals to PLL IC (IC2, pin 2).
5
CK
Outputs clock signal to PLL IC (IC2, pin 3).
6
DATA
Outputs clock signal to PLL IC (IC2, pin 4).
7
8
PTTM
PTTS
Outputs main microphone (HM-126) select signal to the analog switch (IC10) while intercom operation. Outputs optional remote microphone (HM-127) select signal to the analog switch (IC10) while intercom operation.
12
SP
Outputs ON/OFF control signal for the internal speaker to the AF mute circuit (Q32, D23, RL2). Low : While internal speaker is ON.
13
HI/LO
Output port for RF output power (High or Low) select signal. Low : While low power is selected.
14
SEND
15
TMUTE
16 17 19
Input port for the PLL unlock signal. Low : While PLL is locked. Input port for the PTT switch.
67
Outputs the AF mute switch (Q26) RMUTM control signal for main body. Low : While squelched
Outputs the T8 regulator (Q20, Q21) control signal. Low : While transmitting
68
Outputs the AF mute switch (Q27) control signal for the optional remote RMUTS microphone (HM-127). Low : While squelched
Outputs transmit mute signal. High : While transmitting
69
BEEPM Outputs beep audio for main body.
SRXD
Input port for the communication data from sub CPU (LOGIC unit; IC1).
71
BPLVM
Outputs beep audio for the optional remote microphone (HM-127).
Outputs communication data for sub CPU (LOGIC unit; IC1).
75
RESET
Input port for the reset signal.
STXD
100
SRESET
CLRX
Input port for the cloning data from the buffer (D24).
4-5
Outputs the reset signal for sub CPU (LOGIC unit; IC1).
SECTION 5 ADJUSTMENT PROCEDURES 5-1 PREPARATION ■ REQUIRED TEST EQUIPMENT EQUIPMENT
GRADE AND RANGE
EQUIPMENT
DC power supply
Output voltage Current capacity
: 13.8 V DC : 10 A or more
RF power meter (terminated type)
Measuring range Frequency range Impedance SWR
: : : :
Frequency counter
Frequency range : 0.1–300 MHz Frequency accuracy : ±1 ppm or better Sensitivity : 100 mV or better
FM deviation meter
Frequency range Measuring range
DC voltmeter
Input impedance
GRADE AND RANGE Frequency range Measuring range
: 300–3000 Hz : 1–500 mV
Frequency range Output level
: 0.1–300 MHz : 0.1 µV–32 mV (–127 to –17 dBm)
Oscilloscope
Frequency range Measuring range
: DC–20 MHz : 0.01–20 V
AC millivoltmeter
Measuring range
: 10 mV–10 V
: 30–300 MHz : 0 to ±10 kHz
External speaker
Input impedance Capacity
:4Ω : 5 W or more
: 50 kΩ/V DC or better
Attenuator
Power attenuation Capacity
: 40 or 50 dB : 50 W or more
Audio generator
1–50 W 100–300 MHz 50 Ω Less than 1.2 : 1
Standard signal generator (SSG)
‘ CONNECTIONS
Standard signal generator –17 to –125 dBm (32 mV to 0.13 µV)
CAUTION: DO NOT transmit while SSG is connected to the antenna connector. To external speaker
RF power meter 50 Ω / 1–50 W FM deviation meter
– +
Frequency counter
to DC cable
Black
Attenuator 40 dB or 50 dB to the antenna connector
iM502
5-1
DC power supply 13.8 V /15 A
Red
5-2 PLL ADJUSTMENTS ADJUSTMENT LOCK VOLTAGE
ADJUSTMENT CONDITION
1 • Operating channel : ch16 • Receiving
MEASUREMENT UNIT
LOCATION
MAIN
Connect a digital multi-meter or oscilloscope to check point CP1.
2 • Operating channel : ch116 • Receiving Connect a digital multi-meter or oscilloscope to check point CP2.
3 • Operating channel : ch16 • Output power : Low • Transmitting 4 • Operating channel : ch116 • Output power : Low • Transmitting REFERENCE 1 • Operating channel : ch16 • Output power : Low FREQUENCY • Connect an RF power meter or a 50 Ω dummy load to the antenna connector. • Transmitting
Rear Panel
Loosely couple the frequency counter to the antenna connector.
L10
VALUE 3.5 V
ADJUSTMENT POINT UNIT
ADJUST
MAIN
L13
4.5–6.0 V
Verify
2.5 V
L10
2.5–3.5 V
Verify
156.8000 MHz
MAIN
CP2
Lock voltage adjustment for TX
Lock voltage check point for TX
L13
C70
Lock voltage adjustment for RX
Reference frequency adjustment
CP1 Lock voltage check point for RX
5-2
C70
5-3 TRANSMITTER ADJUSTMENTS ADJUSTMENT OUTPUT POWER
ADJUSTMENT CONDITION
1 • Operating channel : ch16 • Output power : High • Transmitting
FREQUENCY 1 • Operating channel : ch16 • Output power : Low DEVIATION • Connect an audio generator to J7 (pin 5) with an AC millivoltmeter and set as: Frequency : 1 kHz Level : 70 mV • Set an FM deviation meter as: HPF : OFF LPF : 20 kHz De-emphasis : OFF Detector : (P–P)/2 • Transmitting
MEASUREMENT
VALUE
ADJUSTMENT POINT
UNIT
LOCATION
UNIT
ADJUST
Rear Panel
Connect an RF power meter to the antenna connector.
25 W
MAIN
R84
Rear Panel
Connect an FM deviation meter to the antenna connector through an attenuator.
±4.3 kHz
MAIN
R172
AC millivoltmeter 2–200 mV +
Audio generator – 300 Hz to 3 kHz
J7 1
[PTT]
8
R172 Frequency deviation adjustment
R84 Output power adjustment
5-3
5-4 RECEIVER ADJUSTMENTS ADJUSTMENT
ADJUSTMENT CONDITION
MEASUREMENT
ADJUSTMENT POINT
VALUE
UNIT
LOCATION
UNIT
ADJUST
SENSITIVITY 1 • Operating channel : ch16 • [SQUELCH] control: Max. counterclockwise • Set the internal speaker OFF in the SET mode, and connect a distortion meter with a 4 Ω load to [EXT SP] receptacle. • Connect an SSG to the antenna connector and set as: Frequency : 156.800 MHz Level : 10 µV* (–97 dBm) Modulation : 1 kHz Deviation : ±3.5 kHz • Receiving
MAIN
Connect a DC voltmeter to check point CP3.
Maximum voltage
MAIN
L1, L2, L3, L4,
1 • Operating channel : ch16 • [SQUELCH] control: Max. counterclockwise • Connect an SSG to the antenna connector and set as: Frequency : 156.800 MHz Level : 0.18 µV* (–122 dBm) Modulation : 1 kHz Deviation : ±3.5 kHz • Receiving
MAIN
Connect a DC voltmeter to check point CP5.
2V
MAIN
R33
SQUELCH
*This output level of a standard signal generator (SSG) is indicated as SSG’s open circuit.
R33 Squelch adjustment
CP3 Receive sensitivity check point
L4 L3 Receive sensitivity adjustment
L2 CP5
L1
Squelch check point
5-4
SECTION 6 PARTS LIST 6-1 IC-M502 [LOGIC UNIT]
[LOGIC UNIT] REF NO.
ORDER NO.
REF NO.
DESCRIPTION
IC1 IC2
1140009280 S.IC 1140008960 S.IC
µPD78F9418AGK-9EU HD66712SA03FS
Q1 Q2 Q3 Q4 Q5 Q6 Q8
1560000810 1530002850 1520000460 1560000810 1590000720 1590000430 1530002850
2SK1069-4-TL 2SC4116-BL (TE85R) 2SB1132 T100 R 2SK1069-4-TL DTA144EUA T106 DTC144EUA T106 2SC4116-BL (TE85R)
D1
1790001010 S.ZENER
MA8043-L (TX)
X1
6060000750 S.CERAMIC
CSTCC4.91MG
R1 R2 R3 R4 R5 R6 R7 R8 R9 R10 R11 R12 R13 R14 R15 R16 R17 R18 R19 R20 R22 R23 R24 R25 R26 R27 R28 R29 R30 R31 R32 R33 R34 R35 R36 R37 R38 R41 R42 R43 R44 R45 R46 R47 R48 R49 R50 R51 R52 R53 R54 R55 R56 R64 R65
7030003640 7030003560 7030003640 7030003560 7030003640 7030003570 7030003460 7030003560 7510001150 7030003560 7030004120 7030003560 7030003590 7030003560 7030004120 7030003560 7030003440 7030003680 7030003640 7030003600 7030003560 7030003460 7030003560 7510001150 7030003560 7030003560 7030003560 7030003560 7030003560 7030003560 7030003560 7030003680 7030003680 7030003680 7030003680 7030003680 7030003360 7030003360 7030003360 7030003360 7030003560 7030003560 7030003610 7030003560 7030003560 7030003680 7030003750 7030003690 7030003560 7030003360 7030003360 7030003560 7030003500 7030003620 7030003800
ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 123 V (12 kΩ) ERJ3GEYJ 152 V (1.5 kΩ) ERJ3GEYJ 103 V (10 kΩ) NTCCM1608 4BH 103KC ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 203 V (20 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 183 V (18 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 203 V (20 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 223 V (22 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 152 V (1.5 kΩ) ERJ3GEYJ 103 V (10 kΩ) NTCCM1608 4BH 103KC ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 221 V (220 Ω) ERJ3GEYJ 221 V (220 Ω) ERJ3GEYJ 221 V (220 Ω) ERJ3GEYJ 221 V (220 Ω) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 273 V (27 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 394 V (390 kΩ) ERJ3GEYJ 124 V (120 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 221 V (220 Ω) ERJ3GEYJ 221 V (220 Ω) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 332 V (3.3 kΩ) ERJ3GEYJ 333 V (33 kΩ) ERJ3GEYJ 105 V (1 MΩ)
S.FET S.TRANSISTOR S.TRANSISTOR S.FET S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR
S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.THERMISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.THERMISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR
ORDER NO.
DESCRIPTION
R66 R67 R68 R69 R70
7030003680 7030003590 7030003560 7030003630 7030003640
S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR
ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ
104 183 103 393 473
V V V V V
(100 kΩ) (18 kΩ) (10 kΩ) (39 kΩ) (47 kΩ)
C1 C2 C3 C4 C5 C6 C7 C8 C9 C11 C12 C13 C14 C15 C16 C17 C18 C19 C20 C21 C22 C23 C24 C25
4030006860 4030006860 4030011600 4030011600 4030006860 4030006860 4030006900 4030006900 4030011600 4510004630 4030006860 4030006900 4030011600 4030006900 4030006900 4510004630 4030006900 4030006900 4030011600 4510004440 4510004440 4030006900 4030011600 4030006900
S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC
C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1C 104KT-N ECEV1CA100SR C1608 JB 1H 102K-T-A C1608 JB 1E 103K-T-A C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A ECEV1CA100SR C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1C 104KT-N ECEV1HA010SR ECEV1HA010SR C1608 JB 1E 103K-T-A C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A
J1 J2 J3 J4
6510021600 6510021440 6510021440 6510022020
S.CONNECTOR S.CONNECTOR S.CONNECTOR S.CONNECTOR
S2B-PH-SM3-TB B6B-ZR-SM3-TF B6B-ZR-SM3-TF 14FLT-SM1-TB
DS1 DS2 DS3 DS4 DS5 DS6 DS7 DS8 DS9 DS10 DS11 DS12 DS13 DS14 DS15 DS16 DS17
5030001880 5040002310 5040002310 5040002310 5040002310 5040002310 5040002310 5040002310 5040002310 5040002310 5040002310 5040002310 5040002310 5040002310 5040002310 5040002310 5040002310
LCD S.LED S.LED S.LED S.LED S.LED S.LED S.LED S.LED S.LED S.LED S.LED S.LED S.LED S.LED S.LED S.LED
TSD0393-UFFDCW SML-311YTT86 SML-311YTT86 SML-311YTT86 SML-311YTT86 SML-311YTT86 SML-311YTT86 SML-311YTT86 SML-311YTT86 SML-311YTT86 SML-311YTT86 SML-311YTT86 SML-311YTT86 SML-311YTT86 SML-311YTT86 SML-311YTT86 SML-311YTT86
S1
2230000250 SWITCH
SPPH22014A
EP1 EP2
8930052590 LCD CONTACT 0910052903 PCB
SRCN-2345-SP-N-W B 5427C
S.=Surface mount 6-1
[VOL UNIT] REF NO.
[MAIN UNIT]
ORDER NO.
REF NO.
DESCRIPTION
R1
7210003080 VARIABLE
TP96N97-15F-10KA-2345
J1
6510009470 CONNECTOR
S3B-ZR
W1
8900009860 CABLE
OPC-970
EP1
0910053363 PCB
B 5428C
[SQL UNIT] REF NO.
ORDER NO.
DESCRIPTION
R1
7210002360 VARIABLE
TP96N97-15F-10KB-1301
W1
8900009870 CABLE
OPC-971
EP1
0910053372 PCB
B 5429B
[DIAL UNIT] REF NO.
ORDER NO.
DESCRIPTION
S1
2250000220 ENCODER
TP90N937E20-15F-1540
EP1
0910053382 PCB
B 5430B
CTRL UNIT] REF NO.
ORDER NO.
DESCRIPTION
IC1
1130005640 S.IC
TC4W53F (TE12L)
D4
1730002360 S.ZENER
MA8062-M (TX)
R1 R2 R3 R4 R5 R6
7030003680 7030003680 7030003800 7030003800 7030003800 7030003680
S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR
ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ
C7 C9 C10 C11 C12 C13 C14 C15
4030006900 4030006900 4510004630 4030012600 4030012600 4030012600 4030006900 4030006900
S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC
C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A ECEV1CA100SR C2012 JB 1A 105M-T-A C2012 JB 1A 105M-T-A C2012 JB 1A 105M-T-A C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A
J1 J2
6510022440 CONNECTOR 6510022020 S.CONNECTOR
LTW-8MP-C 14FLT-SM1-TB
EP1
0910052823 PCB
B 5471C
104 104 105 105 105 104
V V V V V V
(100 kΩ) (100 kΩ) (1 MΩ) (1 MΩ) (1 MΩ) (100 kΩ)
ORDER NO.
DESCRIPTION
IC1 IC2 IC3 IC4 IC5 IC6 IC8 IC9 IC10 IC11 IC12 IC13 IC14 IC15 IC16 IC17 IC18 IC19 IC20 IC21
1110003200 1130007610 1150001540 1110003750 1110003650 1130007420 1110002030 1180001070 1130007690 1110003750 1130007690 1110003750 1110003090 1110004710 1140009270 1140008650 1130007420 1170000280 1120002830 1120002830
S.IC S.IC IC S.IC S.IC S.IC IC S.IC S.IC S.IC S.IC S.IC IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC
TA31136FN (EL) µPD3140GS-E1 (DS8) M57710-A/SC-1302 M5218AFP 600C NJM2211M-TE1 TC7W14FU (TE12L) TA7808S TA7805F (TE16L) BU4066BCF-T1 M5218AFP 600C BU4066BCF-T1 M5218AFP 600C LA4425A S-80928ANMP-DDR-T2 MB90F583BPFV-G HN58X2464TI TC7W14FU (TE12L) TLP121 (GB-TPL) NJM2125F-TE1 NJM2125F-TE1
Q2 Q3 Q4 Q5 Q6 Q7 Q8 Q9 Q10 Q11 Q12 Q14 Q15 Q16 Q17 Q18 Q20 Q21 Q22 Q23 Q24 Q25 Q26 Q27 Q28 Q29 Q30 Q31 Q32 Q33 Q34 Q35 Q36 Q37 Q38 Q39 Q40 Q41 Q42 Q44 Q45 Q46 Q47
1580000700 1580000490 1530002360 1530002600 1560000540 1560000330 1560000330 1530002600 1530002600 1530002240 1530002340 1520000380 1590000430 1590000670 1590000430 1530002850 1520000460 1590000430 1520000460 1590000430 1530002850 1530002850 1590001390 1590001390 1560000810 1590000430 1530002850 1590000430 1530002850 1560000810 1590000720 1590000720 1590000660 1590000660 1530002060 1510000510 1560000810 1590000720 1590000720 1530002850 1530002850 1590001390 1530002550
S.FET S.FET S.TRANSISTOR S.TRANSISTOR S.FET S.FET S.FET S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.FET S.FET S.FET S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.FET S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.FET S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.FET S.TRANSISTOR
3SK292 (TE85R) 3SK166A-2-T7 2SC2714-Y (TE85R) 2SC4215-O (TE85R) 2SK880-Y (TE85R) 2SK210-GR (TE85R) 2SK210-GR (TE85R) 2SC4215-O (TE85R) 2SC4215-O (TE85R) 2SC3775-3-TB 2SC2954-T2B 2SB1143 S DTC144EUA T106 FMW1 T148 DTC144EUA T106 2SC4116-BL (TE85R) 2SB1132 T100 R DTC144EUA T106 2SB1132 T100 R DTC144EUA T106 2SC4116-BL (TE85R) 2SC4116-BL (TE85R) 2SJ144-Y (TE85R) 2SJ144-Y (TE85R) 2SK1069-4-TL DTC144EUA T106 2SC4116-BL (TE85R) DTC144EUA T106 2SC4116-BL (TE85R) 2SK1069-4-TL DTA144EUA T106 DTA144EUA T106 DTC144TU T107 DTC144TU T107 2SC4081 T107 R 2SA1576A T106R 2SK1069-4-TL DTA144EUA T106 DTA144EUA T106 2SC4116-BL (TE85R) 2SC4116-BL (TE85R) 2SJ144-Y (TE85R) 2SC3326-B (TE85R)
D1 D2 D3 D4 D5 D6 D7 D8 D9 D10 D11 D12 D13 D14 D15
1720000260 1720000260 1720000260 1720000260 1790001330 1790000640 1790000640 1790000640 1790000640 1790000640 1790000620 1790000620 1750000550 1790000690 1790000690
S.VARICAP S.VARICAP S.VARICAP S.VARICAP S.ZENER S.VARICAP S.VARICAP S.VARICAP S.VARICAP S.VARICAP S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE
1SV214 (TPH2) 1SV214 (TPH2) 1SV214 (TPH2) 1SV214 (TPH2) MA8036-L (TX) MA363B (TX) MA363B (TX) MA363B (TX) MA363B (TX) MA363B (TX) MA77 (TX) MA77 (TX) 1SS355 TE-17 HSM88ASR-TR HSM88ASR-TR
S.=Surface mount 6-2
[MAIN UNIT] REF NO.
[MAIN UNIT]
ORDER NO.
REF NO.
DESCRIPTION
D16 D17 D18 D19 D20 D21 D22 D23 D24 D26 D27 D28 D29 D31 D32 D33 D34 D35 D36 D37 D38
1710001080 1710001080 1750000550 1790000700 1750000130 1750000130 1750000130 1750000550 1750000130 1720000360 1750000550 1160000050 1750000550 1790000620 1790000620 1790001210 1720000260 1720000260 1720000260 1160000050 1160000050
DIODE DIODE S.DIODE DIODE S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE S.VARICAP S.VARICAP S.VARICAP S.DIODE S.DIODE
XB15A308 XB15A308 1SS355 TE-17 DSA3A1 DA204U T107 DA204U T107 DA204U T107 1SS355 TE-17 DA204U T107 HSU88TRF 1SS355 TE-17 DAP202U T107 1SS355 TE-17 MA77 (TX) MA77 (TX) 1SS375-TL 1SV214 (TPH2) 1SV214 (TPH2) 1SV214 (TPH2) DAP202U T107 DAP202U T107
FI1 FI2 FI3
2010002420 MONOLITH 2010002420 MONOLITH 2020001680 CERAMIC
FL-310 (21R15AB) FL-310 (21R15AB) ALFY450E
X1 X2 X3 X4
6070000210 6050010800 6050011030 6050010290
S.DISCRIMINATOR S.XTAL S.XTAL S.XTAL
CDBCA450CX24 CR-659 (21.25 MHz) DMX-26S (32.768 kHz) CR-610 (7.9872 MHz)
L1 L2 L3 L4 L7 L8 L9 L10 L11 L12 L13 L14 L15 L16 L17 L18 L19 L20 L21 L22 L23 L24 L25 L26 L27 L30 L31 L32 L33 L34
6150003820 6150003820 6150003820 6150003820 6200002410 6200004700 6200003320 6130002370 6200003090 6200003100 6130002360 6200003090 6200004700 6200004700 6200002430 6200002430 6200002600 6200002600 6110001600 6170000230 6110001130 6110001600 6110001670 6110001600 6110001580 6200004600 6200003960 6200003960 6200003640 6200009520
COIL COIL COIL COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL COIL COIL COIL COIL COIL COIL COIL S.COIL S.COIL S.COIL S.COIL S.COIL
LS-440 LS-440 LS-440 LS-440 NL 252018T-056J MLR1608M R10K-T NL 322522T-3R3J-3 LB-258 NL 322522T-2R7J-3 NL 322522T-3R9J-3 LB-257 NL 322522T-2R7J-3 MLR1608M R10K-T MLR1608M R10K-T NL 252018T-082J NL 252018T-082J NL 252018T-047J NL 252018T-047J LA-243 LW-25 LA-149 LA-243 LA-253 LA-243 LA-238 MLF1608D R15K-T MLF1608A 1R0K-T MLF1608A 1R0K-T MLF1608E 100K-T LQS33N 1R0G04
R1 R2 R3 R4 R5 R6 R7 R8 R9 R10 R11 R12 R16 R18 R19 R20
7030003270 7030003720 7030003620 7030003600 7030003560 7030003640 7030003320 7030003400 7030003320 7030003720 7030003720 7030003720 7030003560 7030003560 7030003200 7030003480
S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR
ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ
390 224 333 223 103 473 101 471 101 224 224 224 103 103 100 222
V V V V V V V V V V V V V V V V
R21 R22 R23 R25 R26 R27 R28 R29 R30 R31 R32 R33 R35 R36 R37 R38 R39 R40 R41 R42 R43 R44 R45 R55 R56 R57 R58 R59 R60 R61 R62 R63 R64 R65 R66 R67 R68 R69 R70 R71 R72 R73 R74 R75 R76 R77 R78 R79 R80 R81 R82 R83 R84 R85 R86 R87 R88 R90 R95 R96 R97 R98 R99 R100 R101 R102 R103 R104 R105 R106 R107 R108 R109 R110 R111 R112 R113 R114 R115 R116 R117 R118
(39 Ω) (220 kΩ) (33 kΩ) (22 kΩ) (10 kΩ) (47 kΩ) (100 Ω) (470 Ω) (100 Ω) (220 kΩ) (220 kΩ) (220 kΩ) (10 kΩ) (10 kΩ) (10 Ω) (2.2 kΩ)
ORDER NO. 7030003450 7030003460 7030003680 7030003500 7030003400 7030003450 7030003390 7030003460 7030003740 7030003430 7030003620 7310003590 7030003660 7030003420 7030003320 7030003300 7030003320 7030003280 7030003380 7030003640 7030003440 7030003560 7410000950 7030003660 7030003420 7030003320 7030003320 7030003500 7030003480 7030003360 7030003440 7030003480 7030003270 7030003480 7030003390 7030003560 7030003560 7030003320 7030003200 7030003440 7030003320 7030004700 7030003440 7030003200 7030003640 7030003530 7030003500 7030003560 7030003340 7030003480 7030003480 7030003560 7310002670 7030003600 7030003800 7030003680 7030001150 7030003280 7030003680 7030003680 7030003560 7030003550 7030003460 7030003760 7030003760 7030003560 7030003560 7030003560 7030003760 7030003640 7030003680 7030003630 7030003580 7310002720 7030003380 7030003560 7030003480 7030003560 7030003480 7030003280 7030003440 7030003550
DESCRIPTION S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.TRIMMER S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.ARRAY S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.TRIMMER S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.TRIMMER S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR
ERJ3GEYJ 122 V (1.2 kΩ) ERJ3GEYJ 152 V (1.5 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 332 V (3.3 kΩ) ERJ3GEYJ 471 V (470 Ω) ERJ3GEYJ 122 V (1.2 kΩ) ERJ3GEYJ 391 V (390 Ω) ERJ3GEYJ 152 V (1.5 kΩ) ERJ3GEYJ 334 V (330 kΩ) ERJ3GEYJ 821 V (820 Ω) ERJ3GEYJ 333 V (33 kΩ) EVM-1XSX50 B24 (203) ERJ3GEYJ 683 V (68 kΩ) ERJ3GEYJ 681 V (680 Ω) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 680 V (68 Ω) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 470 V (47 Ω) ERJ3GEYJ 331 V (330 Ω) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 103 V (10 kΩ) EXB-V8V 102JV ERJ3GEYJ 683 V (68 kΩ) ERJ3GEYJ 681 V (680 Ω) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 332 V (3.3 kΩ) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 221 V (220 Ω) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 390 V (39 Ω) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 391 V (390 Ω) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 100 V (10 Ω) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 101 V (100 Ω) MCR18EZHJ 10 Ω (100) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 100 V (10 Ω) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 562 V (5.6 kΩ) ERJ3GEYJ 332 V (3.3 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 151 V (150 Ω) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 103 V (10 kΩ) RV-143 (RH03A3AS2) 471 ERJ3GEYJ 223 V (22 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 104 V (100 kΩ) MCR50JZHJ 150 Ω (151) ERJ3GEYJ 470 V (47 Ω) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 822 V (8.2 kΩ) ERJ3GEYJ 152 V (1.5 kΩ) ERJ3GEYJ 474 V (470 kΩ) ERJ3GEYJ 474 V (470 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 474 V (470 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 393 V (39 kΩ) ERJ3GEYJ 153 V (15 kΩ) RV-148 (RH03A3AS3X0DA) 472 ERJ3GEYJ 331 V (330 Ω) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 470 V (47 Ω) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 822 V (8.2 kΩ)
S.=Surface mount 6-3
[MAIN UNIT] REF NO. R119 R120 R121 R122 R123 R124 R125 R126 R127 R128 R129 R130 R131 R132 R133 R134 R135 R136 R137 R140 R141 R142 R143 R144 R145 R147 R148 R149 R150 R151 R152 R153 R154 R155 R156 R157 R158 R159 R160 R161 R162 R163 R164 R165 R166 R167 R168 R169 R170 R171 R172 R173 R174 R175 R176 R177 R178 R179 R180 R181 R182 R183 R184 R185 R186 R187 R188 R189 R190 R191 R192 R193 R194 R199 R200 R201 R202 R203 R204 R205 R208 R209
[MAIN UNIT]
ORDER NO. 7030003550 7030003770 7030003710 7030003490 7030003380 7030003620 7030003620 7030003480 7030003680 7030003760 7030003760 7030003680 7030003680 7030003680 7030003680 7030003440 7030003800 7030003800 7030003490 7030003320 7030003440 7030003800 7030003580 7030003590 7030003800 7030003450 7030003590 7030003630 7030003590 7030003800 7030003800 7030003640 7030003800 7030003800 7030003800 7030003290 7030003600 7030003620 7030003800 7030003570 7030003670 7030003800 7030003680 7030003700 7030003670 7030003670 7030003560 7510001150 7030003570 7030003570 7310002600 7030003590 7030003620 7030003550 7030003280 7030003580 7030003450 7030003800 7030003600 7030000100 7030003630 7030003630 7030003680 7030003680 7030003680 7030003800 7030003750 7030003800 7030003200 7030003680 7030003490 7030003610 7030003680 7030003680 7030003680 7030003680 7030003680 7030003680 7030003700 7030003640 7030003680 7030003440
REF NO.
DESCRIPTION S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.THERMISTOR S.RESISTOR S.RESISTOR S.TRIMMER S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR
ERJ3GEYJ 822 V (8.2 kΩ) ERJ3GEYJ 564 V (560 kΩ) ERJ3GEYJ 184 V (180 kΩ) ERJ3GEYJ 272 V (2.7 kΩ) ERJ3GEYJ 331 V (330 Ω) ERJ3GEYJ 333 V (33 kΩ) ERJ3GEYJ 333 V (33 kΩ) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 474 V (470 kΩ) ERJ3GEYJ 474 V (470 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 272 V (2.7 kΩ) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 153 V (15 kΩ) ERJ3GEYJ 183 V (18 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 122 V (1.2 kΩ) ERJ3GEYJ 183 V (18 kΩ) ERJ3GEYJ 393 V (39 kΩ) ERJ3GEYJ 183 V (18 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 560 V (56 Ω) ERJ3GEYJ 223 V (22 kΩ) ERJ3GEYJ 333 V (33 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 123 V (12 kΩ) ERJ3GEYJ 823 V (82 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 154 V (150 kΩ) ERJ3GEYJ 823 V (82 kΩ) ERJ3GEYJ 823 V (82 kΩ) ERJ3GEYJ 103 V (10 kΩ) NTCCM1608 4BH 103KC ERJ3GEYJ 123 V (12 kΩ) ERJ3GEYJ 123 V (12 kΩ) RV-110 (RH03A3AS4X0AA) 473 ERJ3GEYJ 183 V (18 kΩ) ERJ3GEYJ 333 V (33 kΩ) ERJ3GEYJ 822 V (8.2 kΩ) ERJ3GEYJ 470 V (47 Ω) ERJ3GEYJ 153 V (15 kΩ) ERJ3GEYJ 122 V (1.2 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 223 V (22 kΩ) MCR10EZHJ 4.7 Ω (4R7) ERJ3GEYJ 393 V (39 kΩ) ERJ3GEYJ 393 V (39 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 394 V (390 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 100 V (10 Ω) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 272 V (2.7 kΩ) ERJ3GEYJ 273 V (27 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 154 V (150 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 102 V (1 kΩ)
R210 R211 R212 R218 R219 R220 R221 R222 R223 R224 R225 R226 R227 R228 R229 R230 R231 R233 R234 R235 R236 R237 R238 R239 R240 R241 R242 R246 R247 R248 R249 R250 R251 R252 R253 R254 R255 R256 R257 R258 R259 R260 R261 R262 R263 R264 R265 R266 R267 R268 R270 R276 R277 R278 R280 R281 R283 R284 R285 R286 R287 R288 R289 R290 R291 R292 R293 R294 R295 R296 R297 R298 R299 R300 R301 R302 R303 R304
ORDER NO. 7030003800 7030003650 7030003490 7030003560 7030003680 7030003680 7030003680 7030003680 7030003680 7030003680 7030003640 7030003640 7030003580 7030003440 7030003440 7030003520 7030003280 7030003440 7030003640 7030003440 7030003540 7030003400 7030003680 7030003680 7030003680 7030003350 7030003240 7030003680 7030003600 7030003640 7030003620 7030003280 7030003310 7030003520 7030003550 7030003410 7030003440 7030003590 7030003440 7030003440 7030003200 7030003590 7030003520 7030003480 7030003560 7030003560 7030003560 7030003440 7030003560 7030003440 7030003530 7030003280 7030003480 7030003480 7030003560 7030003430 7510001050 7030003680 7030003680 7030003680 7030004050 7030003560 7030003500 7030003610 7030003640 7030003690 7030003380 7030003680 7030003560 7030003560 7030003440 7030003560 7030003560 7030003560 7030000320 7030000320 7030000320 7030003380
DESCRIPTION S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.THERMISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR
ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 563 V (56 kΩ) ERJ3GEYJ 272 V (2.7 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 153 V (15 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 472 V (4.7 kΩ) ERJ3GEYJ 470 V (47 Ω) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 682 V (6.8 kΩ) ERJ3GEYJ 471 V (470 Ω) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 181 V (180 Ω) ERJ3GEYJ 220 V (22 Ω) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 223 V (22 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 333 V (33 kΩ) ERJ3GEYJ 470 V (47 Ω) ERJ3GEYJ 820 V (82 Ω) ERJ3GEYJ 472 V (4.7 kΩ) ERJ3GEYJ 822 V (8.2 kΩ) ERJ3GEYJ 561 V (560 Ω) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 183 V (18 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 100 V (10 Ω) ERJ3GEYJ 183 V (18 kΩ) ERJ3GEYJ 472 V (4.7 kΩ) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 562 V (5.6 kΩ) ERJ3GEYJ 470 V (47 Ω) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 821 V (820 Ω) NTCCM1608 4LH 333KC-T ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 1R0 V (1 Ω) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 332 V (3.3 kΩ) ERJ3GEYJ 273 V (27 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 124 V (120 kΩ) ERJ3GEYJ 331 V (330 Ω) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) MCR10EZHJ 330 Ω (331) MCR10EZHJ 330 Ω (331) MCR10EZHJ 330 Ω (331) ERJ3GEYJ 331 V (330 Ω)
S.=Surface mount 6-4
[MAIN UNIT] REF NO. C1 C2 C3 C4 C5 C6 C7 C8 C9 C10 C11 C12 C13 C14 C15 C16 C17 C18 C19 C20 C21 C22 C23 C24 C25 C26 C27 C28 C31 C32 C33 C34 C36 C38 C39 C40 C42 C43 C45 C46 C47 C48 C49 C50 C51 C52 C53 C54 C55 C56 C57 C58 C59 C60 C62 C63 C64 C65 C66 C67 C68 C69 C70 C71 C72 C74 C77 C79 C81 C96 C97 C98 C99 C100 C101 C102 C103 C104 C105 C106 C107 C108
ORDER NO. 4030009510 4030007010 4030009570 4030007030 4030009520 4030006860 4030006860 4030006850 4030006860 4030006860 4030006860 4030006850 4030009540 4030007030 4030006860 4030009530 4030006860 4030007030 4030006860 4030009520 4030009500 4030009520 4030009520 4030007030 4030006860 4030006900 4030006860 4030007010 4030007090 4030008880 4030006860 4030006860 4030011770 4030006860 4030006900 4030006860 4030008880 4030006860 4030007080 4030007080 4030006860 4030011810 4030011600 4030006860 4030006860 4030011600 4030007130 4030007090 4030006900 4510004630 4030006900 4030006860 4030011600 4030006860 4030012600 4030007170 4030007170 4030006860 4030009920 4030009990 4030006860 4030007040 4610002150 4030007010 4030006860 4030006860 4030006860 4030008880 4030006900 4030006860 4030006900 4030007020 4030006860 4030006860 4030007020 4030006860 4030006860 4030006860 4030006860 4030007090 4030006860 4030006860
[MAIN UNIT] REF NO.
DESCRIPTION S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TRIMMER S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC
C1608 CH 1H 010B-T-A C1608 CH 1H 100D-T-A C1608 CH 1H 0R3B-T-A C1608 CH 1H 150J-T-A C1608 CH 1H 020B-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 471K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 471K-T-A C1608 CH 1H 1R5B-T-A C1608 CH 1H 150J-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 030B-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 150J-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 020B-T-A C1608 CH 1H 0R5B-T-A C1608 CH 1H 020B-T-A C1608 CH 1H 020B-T-A C1608 CH 1H 150J-T-A C1608 JB 1H 102K-T-A C1608 JB 1E 103K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 100D-T-A C1608 CH 1H 470J-T-A C1608 JB 1C 223K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 060B-T-A C1608 JB 1H 102K-T-A C1608 JB 1E 103K-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 223K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 390J-T-A C1608 CH 1H 390J-T-A C1608 JB 1H 102K-T-A C1608 JB 1A 224K-T-N C1608 JB 1C 104KT-N C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N C1608 CH 1H 101J-T-A C1608 CH 1H 470J-T-A C1608 JB 1E 103K-T-A ECEV1CA100SR C1608 JB 1E 103K-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N C1608 JB 1H 102K-T-A C2012 JB 1A 105M-T-A C1608 CH 1H 221J-T-A C1608 CH 1H 221J-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 050B-T-A C1608 CH 1H 200J-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 180J-T-A CTZ3S-10A-W1-AF C1608 CH 1H 100D-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 223K-T-A C1608 JB 1E 103K-T-A C1608 JB 1H 102K-T-A C1608 JB 1E 103K-T-A C1608 CH 1H 120J-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 120J-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 470J-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A
C109 C110 C111 C112 C113 C114 C115 C116 C117 C118 C119 C120 C123 C124 C125 C126 C127 C128 C129 C130 C131 C132 C133 C134 C136 C137 C138 C139 C141 C142 C143 C148 C149 C150 C151 C152 C153 C154 C155 C156 C157 C158 C159 C160 C161 C162 C163 C164 C165 C166 C167 C171 C172 C173 C174 C175 C176 C177 C178 C179 C182 C183 C184 C185 C186 C188 C189 C190 C191 C192 C193 C194 C195 C196 C197 C198 C199 C200 C202 C203 C204 C205
ORDER NO. 4030007040 4030006860 4030006860 4030009510 4030006860 4030006860 4550002830 4030007050 4030007040 4030007080 4030007040 4510006240 4030006860 4510004440 4030006900 4030006860 4030011290 4030011170 4030006860 4030006860 4030006860 4030006860 4030011260 4030011100 4030011140 4030011070 4030011190 4030011060 4030011210 4030011190 4030011730 4030011600 4030006900 4030006900 4030006900 4030006900 4030008850 4030008900 4030008900 4030006850 4030008920 4030011600 4030011810 4030011600 4340000020 4030011600 4030006870 4030006900 4030006850 4030006860 4030006860 4510004630 4030011600 4030011600 4510004630 4510004630 4030011600 4030011600 4030006900 4510004590 4550006130 4030008890 4030008890 4030006870 4030009490 4510004630 4030012600 4030010770 4030010770 4030012600 4030012600 4030011600 4030006900 4030011600 4030006900 4030011600 4030011600 4030011600 4030007090 4030011600 4030011600 4030011600
DESCRIPTION S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.MYLAR S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC ELECTROLYTIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC
C1608 CH 1H 180J-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 010B-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A TESVD2 1V 685M-12R C1608 CH 1H 220J-T-A C1608 CH 1H 180J-T-A C1608 CH 1H 390J-T-A C1608 CH 1H 180J-T-A ECEV1CA221P C1608 JB 1H 102K-T-A ECEV1HA010SR C1608 JB 1E 103K-T-A C1608 JB 1H 102K-T-A GRM42-6 CH 240J 500PT GRM42-6 CH 180J 500PT C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A GRM42-6 W5R 102K 500PT GRM42-6 CH 080D 500PT GRM42-6 CH 120J 500PT GRM42-6 CH 050C 500PT GRM42-6 CH 270J 500PT GRM42-6 CH 040C 500PT GRM42-6 CH 330J 500PT GRM42-6 CH 270J 500PT GRM42-6 CH 101J 500PT C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1C 123K-T-A C1608 JB 1C 333K-T-A C1608 JB 1C 333K-T-A C1608 JB 1H 471K-T-A C1608 JB 1C 473K-T-A C1608 JB 1C 104KT-N C1608 JB 1A 224K-T-N C1608 JB 1C 104KT-N ECWU 1C 333JB5 C1608 JB 1C 104KT-N C1608 JB 1H 222K-T-A C1608 JB 1E 103K-T-A C1608 JB 1H 471K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A ECEV1CA100SR C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N ECEV1CA100SR ECEV1CA100SR C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A 16 MV 470 HC ECST1VY224R C1608 JB 1C 273K-T-A C1608 JB 1C 273K-T-A C1608 JB 1H 222K-T-A C1608 JB 1H 821K-T-A ECEV1CA100SR C2012 JB 1A 105M-T-A C1608 JB 1H 392K-T-A C1608 JB 1H 392K-T-A C2012 JB 1A 105M-T-A C2012 JB 1A 105M-T-A C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 CH 1H 470J-T-A C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N
S.=Surface mount 6-5
[MAIN UNIT] REF NO. C206 C207 C208 C209 C210 C212 C213 C214 C215 C217 C218 C219 C222 C223 C224 C225 C226 C227 C228 C229 C231 C232 C233 C234 C235 C236 C238 C239 C240 C241 C242 C243 C244 C245 C246 C248 C249 C250 C251 C252 C253 C254 C255 C256 C257 C258 C259 C262 C263 C274 C275 C276 C278 C279 C282 C283 C284 C285 C286 C287 C288 C289 C290 C291 C292 C293 C294 C295 C296 C297 C298 C299 C300 C301 C302 C303 C304 C305 C306 C307 C308 C309
ORDER NO. 4030007090 4030006860 4030006850 4030006900 4030006850 4030011810 4030007090 4030008900 4030006850 4030006900 4030011600 4030011600 4030011600 4030011600 4030007050 4030006860 4030010770 4030007120 4030008470 4030007090 4030006900 4510004630 4030011600 4030006900 4510004630 4030011600 4030006900 4030012600 4030012600 4030006860 4030011600 4510004590 4510004590 4030011600 4030011810 4030008890 4030007010 4030007070 4030009650 4030009650 4030011600 4030006900 4030011600 4510004630 4030011600 4030011600 4030011600 4030011600 4030006880 4030006860 4030006860 4030006860 4030006860 4030006860 4030011600 4030006860 4030009510 4030006860 4030011600 4030006980 4030009910 4030009530 4030009500 4030009500 4550006130 4030011600 4550006560 4550006810 4550006810 4030009510 4030009520 4030009910 4030006860 4030011600 4030009560 4030006860 4030011810 4030011810 4030011600 4030011810 4030011600 4030011810
[MAIN UNIT] REF NO.
DESCRIPTION S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC ELECTROLYTIC ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.TANTALUM S.TANTALUM S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC
C1608 CH 1H 470J-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 471K-T-A C1608 JB 1E 103K-T-A C1608 JB 1H 471K-T-A C1608 JB 1A 224K-T-N C1608 CH 1H 470J-T-A C1608 JB 1C 333K-T-A C1608 JB 1H 471K-T-A C1608 JB 1E 103K-T-A C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 CH 1H 220J-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 392K-T-A C1608 CH 1H 820J-T-A C1608 JB 1H 272K-T-A C1608 CH 1H 470J-T-A C1608 JB 1E 103K-T-A ECEV1CA100SR C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A ECEV1CA100SR C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A C2012 JB 1A 105M-T-A C2012 JB 1A 105M-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N 16 MV 470 HC 16 MV 470 HC C1608 JB 1C 104KT-N C1608 JB 1A 224K-T-N C1608 JB 1C 273K-T-A C1608 CH 1H 100D-T-A C1608 CH 1H 330J-T-A C1608 CH 1H 240J-T-A C1608 CH 1H 240J-T-A C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A C1608 JB 1C 104KT-N ECEV1CA100SR C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1H 472K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N C1608 JB 1H 102K-T-A C1608 CH 1H 010B-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N C1608 CH 1H 070D-T-A C1608 CH 1H 040B-T-A C1608 CH 1H 030B-T-A C1608 CH 1H 0R5B-T-A C1608 CH 1H 0R5B-T-A ECST1VY224R C1608 JB 1C 104KT-N ECST1CY225R ECST1VY473R ECST1VY473R C1608 CH 1H 010B-T-A C1608 CH 1H 020B-T-A C1608 CH 1H 040B-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N C1608 CH 1H R75B-T-A C1608 JB 1H 102K-T-A C1608 JB 1A 224K-T-N C1608 JB 1A 224K-T-N C1608 JB 1C 104KT-N C1608 JB 1A 224K-T-N C1608 JB 1C 104KT-N C1608 JB 1A 224K-T-N
ORDER NO.
DESCRIPTION
C312 C314 C315 C316 C317 C318 C319 C321 C326 C327 C328 C330 C331 C332 C333 C334 C335 C337
4030006900 4550006700 4030006860 4030006860 4550006700 4550006700 4030011600 4030007090 4030006900 4030006860 4030011600 4030006860 4030006900 4030009510 4030012600 4030011600 4030006900 4510004630
S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.TANTALUM S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC
RL1 RL2
6330001620 RELAY 6330001620 RELAY
FTR-F3AA012E FTR-F3AA012E
J1 J2 J3 J4 J6 J7 J8
6510021300 6510018960 6510022020 6510022020 6510016430 6510018920 6510018960
52365-1091 B2B-PH-SM3-TB 14FLT-SM1-TB 14FLT-SM1-TB 53307-1491 B8B-PH-SM3-TB B2B-PH-SM3-TB
W1 W5 W6
8900010210 CABLE 7030003860 S.JUMPER 7030003860 S.JUMPER
OPC-1026 ERJ3GE JPW V ERJ3GE JPW V
EP1
0910053352 PCB
B 5545B
S.CONNECTOR S.CONNECTOR S.CONNECTOR S.CONNECTOR S.CONNECTOR S.CONNECTOR S.CONNECTOR
C1608 JB 1E 103K-T-A ECST1AY106R C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A ECST1AY106R ECST1AY106R C1608 JB 1C 104KT-N C1608 CH 1H 470J-T-A C1608 JB 1E 103K-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N C1608 JB 1H 102K-T-A C1608 JB 1E 103K-T-A C1608 CH 1H 010B-T-A C2012 JB 1A 105M-T-A C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A ECEV1CA100SR
[PWR-CORD UNIT] REF NO.
ORDER NO.
DESCRIPTION
C1 C2
4030006860 S.CERAMIC 4030006860 S.CERAMIC
C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A
J1
6510003130 CONNECTOR
SB4P-HVQ-22
EP1
0910053340 PCB
B 5559
S.=Surface mount 6-6
6-2 HM-126
6-3 HM-127
[MAIN UNIT]
[MAIN UNIT]
REF NO.
ORDER NO.
R1 R2 R3 R4 R5
7010006890 7010006880 7010006900 7010006910 7070000860
C1
4010000460 CERAMIC
DD104 B 471K 50V
J1
6510003550 CONNECTOR
S07B-EH-S
RESISTOR RESISTOR RESISTOR RESISTOR RESISTOR
R20J 12 kΩ R20J 6.8 kΩ R20J 15 kΩ R20J 33 kΩ ERG2SJ 150
MC1
7700001600 MICROPHONE
KUC2123-030245
S1 S2 S3 S4
2260000980 2260000080 2260000080 2260000080
SKHHLP014A SKHHAM024A SKHHAM024A SKHHAM024A
SP1
2510000930 SPEAKER
EP1 EP2
REF NO.
DESCRIPTION
SWITCH SWITCH SWITCH SWITCH
0910052553 PCB 9029701901 TUBE
ORDER NO.
DESCRIPTION
IC1 IC2 IC3 IC4 IC5 IC6 IC7 IC8 IC9
1140009280 1110001810 1110004490 1120002830 1180000420 1180001250 1110004710 1130007420 1130006220
S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC
µPD78F9418AGK-9EU TA7368F (TP1) M62429FP 700C NJM2125F-TE1 TA78L05F (TE12R) TA7808F (TE16L) S-80928ANMP-DDR-T2 TC7W14FU (TE12L) TC4W53FU (TE12L)
Q1 Q2 Q3 Q4 Q5 Q6 Q9 Q10 Q11 Q12
1560000810 1520000460 1530002850 1590001390 1590000430 1590000980 1560000810 1530002060 1510000510 1530002850
S.FET S.TRANSISTOR S.TRANSISTOR S.FET S.TRANSISTOR S.TRANSISTOR S.FET S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR
2SK1069-4-TL 2SB1132 T100 R 2SC4116-BL (TE85R) 2SJ144-Y (TE85R) DTC144EUA T106 DTB123EK T147 2SK1069-4-TL 2SC4081 T107 R 2SA1576A T106R 2SC4116-BL (TE85R)
D1 D2 D3
1750000130 S.DIODE 1160000060 S.DIODE 1750000550 S.DIODE
DA204U T107 DAN202U T107 1SS355 TE-17
X1
6060000750 S.CERAMIC
CSTCC4.91MG
R1 R2 R3 R6 R7 R8 R9 R10 R11 R12 R13 R14 R15 R16 R17 R18 R19 R20 R21 R22 R23 R24 R25 R26 R27 R28 R29 R30 R31 R32 R33 R34 R35 R36 R37 R38 R39 R40 R41 R42 R43 R44 R45 R46 R47 R50 R51 R52 R53
7030000270 7030000270 7030000280 7030003560 7030003560 7030003560 7030003560 7030003680 7030003680 7030003680 7030003680 7030003680 7030003680 7030003680 7030003680 7030003680 7030003800 7030003540 7030003630 7030004120 7030003560 7030003450 7030003560 7510001150 7030003560 7030004120 7030003560 7030003590 7030003560 7030004120 7030003560 7030003440 7030003440 7030003560 7030003600 7030003580 7030003680 7030003760 7030003680 7030003570 7030003490 7030003680 7030003680 7030003620 7030003760 7030003680 7030003610 7030003630 7030003680
MCR10EZHJ 120 Ω (121) MCR10EZHJ 120 Ω (121) MCR10EZHJ 150 Ω (151) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 682 V (6.8 kΩ) ERJ3GEYJ 393 V (39 kΩ) ERJ3GEYJ 203 V (20 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 122 V (1.2 kΩ) ERJ3GEYJ 103 V (10 kΩ) NTCCM1608 4BH 103KC ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 203 V (20 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 183 V (18 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 203 V (20 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 223 V (22 kΩ) ERJ3GEYJ 153 V (15 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 474 V (470 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 123 V (12 kΩ) ERJ3GEYJ 272 V (2.7 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 333 V (33 kΩ) ERJ3GEYJ 474 V (470 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 273 V (27 kΩ) ERJ3GEYJ 393 V (39 kΩ) ERJ3GEYJ 104 V (100 kΩ)
SU-36W08040C
B 5431C IRRAX 0.7 (d) L=4 mm
S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.THERMISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR
S.=Surface mount 6-7
[MAIN UNIT]
[MAIN UNIT]
REF NO.
ORDER NO.
R54 R55 R56 R57 R58 R59 R60 R61 R62 R63 R64 R65 R66 R67 R68 R69 R70 R75 R76 R77
7030003440 7030003640 7030003440 7030003520 7030003280 7030003580 7030003560 7030003630 7030003640 7030003560 7030003510 7030003800 7030003800 7030003800 7030003320 7030003320 7030003260 7030000180 7030000180 7030000180
S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR
ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 472 V (4.7 kΩ) ERJ3GEYJ 470 V (47 Ω) ERJ3GEYJ 153 V (15 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 393 V (39 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 392 V (3.9 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 330 V (33 Ω) MCR10EZHJ 22 Ω (220) MCR10EZHJ 22 Ω (220) MCR10EZHJ 22 Ω (220)
C1 C3 C4 C5 C6 C7 C9 C10 C11 C12 C13 C14 C15 C16 C17 C18 C22 C23 C24 C25 C26 C27 C28 C29 C30 C31 C32 C33 C34 C35 C36 C37 C38 C39 C40 C41 C42 C44 C45 C46 C47 C50 C51 C52 C53 C54
4510004630 4510005430 4030006900 4030006900 4030006900 4030011600 4030006900 4030011600 4030011600 4030012600 4030008920 4030011600 4510006220 4510006220 4510006220 4510006250 4030006900 4510005430 4030012600 4030006900 4030012600 4030006850 4030011600 4030006860 4510004630 4030011810 4030007090 4030012600 4030011600 4510005430 4030011600 4510005430 4030011600 4510006220 4030011600 4510006250 4030008890 4030011600 4030006900 4030011600 4030006850 4030006860 4030007090 4030007090 4030006900 4030012600
S.ELECTROLYTIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.ELECTROLYTIC S.ELECTROLYTIC S.ELECTROLYTIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC
ECEV1CA100SR ECEV0JA220SR C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C2012 JB 1A 105M-T-A C1608 JB 1C 473K-T-A C1608 JB 1C 104KT-N ECEV1CA101UP ECEV1CA101UP ECEV1CA101UP ECEV1CA331UP C1608 JB 1E 103K-T-A ECEV0JA220SR C2012 JB 1A 105M-T-A C1608 JB 1E 103K-T-A C2012 JB 1A 105M-T-A C1608 JB 1H 471K-T-A C1608 JB 1C 104KT-N C1608 JB 1H 102K-T-A ECEV1CA100SR C1608 JB 1A 224K-T-N C1608 CH 1H 470J-T-A C2012 JB 1A 105M-T-A C1608 JB 1C 104KT-N ECEV0JA220SR C1608 JB 1C 104KT-N ECEV0JA220SR C1608 JB 1C 104KT-N ECEV1CA101UP C1608 JB 1C 104KT-N ECEV1CA331UP C1608 JB 1C 273K-T-A C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A C1608 JB 1C 104KT-N C1608 JB 1H 471K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 470J-T-A C1608 CH 1H 470J-T-A C1608 JB 1E 103K-T-A C2012 JB 1A 105M-T-A
J1 J2
6510019420 S.CONNECTOR 6510021440 S.CONNECTOR
B8B-ZR-SM3-TF B6B-ZR-SM3-TF
DS1 DS2 DS3 DS4 DS5 DS6 DS7 DS8
5030001900 5040002660 5040002660 5040002310 5040002660 5040002660 5040002310 5040002310
A0119 (LCD36*28.5) FY1101F-TR (LED) FY1101F-TR (LED) SML-311YTT86 FY1101F-TR (LED) FY1101F-TR (LED) SML-311YTT86 SML-311YTT86
REF NO.
DESCRIPTION
LCD S.LED S.LED S.LED S.LED S.LED S.LED S.LED
ORDER NO.
DESCRIPTION
DS9 5040002310 S.LED DS10 5040002310 S.LED
SML-311YTT86 SML-311YTT86
MC1
7700002480 MICROPHONE
SKB-2746 LPC
S1 S2 S3 S4
2260002140 2260002140 2260002140 2260002140
SKQLLC SKQLLC SKQLLC SKQLLC
EP1 EP2
0910053142 PCB 8930051120 LCD CONTACT
S.SWITCH S.SWITCH S.SWITCH S.SWITCH
B 5526B SRCN-2320-SP-N-W
S.=Surface mount 6-8
SECTION 7
MECHANICAL PARTS
7-1 IC-M502 [CHASSIS PARTS] REF. NO.
ORDER NO.
[LOGIC UNIT] DESCRIPTION
QTY.
REF. NO.
ORDER NO.
DESCRIPTION
QTY.
J2
6510004880
Antenna connector MR-DS-E 01
1
S1
2230000250
Switch SPPH22014A
1
W1
8900009720
Cable OPC-943
1
DS1
5030001880
LCD TSD0393-UFFDCW
1
EP1
6950000420
Cover LTD-4/8-IC
1
EP1
8930052590
LCD contact SRCN-2345-SP-N-W
2
MP1
8210017191 8210017172 8210017150 8210017160 8410002400 8930052060 8930052050 8610010851 8610010891 8610010861 8610010901 8930051970 8510013460 8110007180 8930052280 8930052290 8930034300 8930049320 8810008660 8810008660 8810008660 8810008660 8810008660 8810008660 8810004540 8810004540 8850000690 8810006050 8930052430 8930052440 8930053030 8930053030 8010004340
2345 front panel-1 assembly 2345 front panel (A)-1 assembly 2345 rear panel assembly 2345 rear panel (A) assembly 2345 A-heatsink 2345 F-packing 2345 R-packing Knob N279-1 Knob N279 (A)-1 Knob N280-1 Knob N280 (A)-1 2345 A-bush plate 2345 module cover assembly 2345 shield cover O-ring (AC) O-ring (AD) 1542 ANT seal 2288 VENT. sheet Screw PH BT M3 × 8 NI-ZU Screw PH BT M3 × 8 NI-ZU Screw PH BT M3 × 8 NI-ZU Screw PH BT M3 × 8 NI-ZU Screw PH BT M3 × 8 NI-ZU Screw PH BT M3 × 8 NI-ZU Screw M3 × 8 SUS Screw M3 × 8 SUS Flat washer M3 (3×7×0.5) SUS Icom screw E 7 2345 A-IC clip 2345 B-IC clip 2345 earth plate 2345 earth plate Edging rubber FX452
1 1 1 1 1 1 1 2 2 1 1 1 1 1 3 6 1 1 1 2 2 5 4 5 2 6 6 6 1 1 1 1 1
MP1 MP2 MP3
8210016830 8930052000 8930052630
2345 reflector 2345 LCD holder 2345 LCD filter
1 1 1
MP2 MP3 MP5 MP6 MP7 MP8 MP9 MP12 MP18 MP21 MP22 MP27 MP29 MP30 MP31 MP33 MP34 MP35 MP36 MP37 MP38 MP40 MP41 MP43 MP44 MP45 MP46 MP47
[BLACK] [WHITE] [BLACK] [WHITE]
[BLACK] [WHITE] [BLACK] [WHITE]
[UNPACKING] REF. NO.
ORDER NO.
DESCRIPTION
W1
8900009751
Cable OPC-946A
MP1
8010018151 8010018241 8610010560 8610010590 8810001490 8850000180 8850000500 8950005110 8810004700
2345 mobile bracket-1 2345 mobile bracket (A)-1 2040 knob bolt 2040 knob bolt (A) Screw PH A M5 × 20 SUS Flat washer M5 SUS Spring washer M5 SUS 2289 MIC hanger Screw PH A M3 × 16 SUS
MP2 MP4 MP5 MP6 MP8 MP9
Screw abbreviations
MP1
QTY. 1
BT: Self-tapping NI: Nickel NI-ZU: Nickel-zinc
MP8
[BLACK] [WHITE] [BLACK] [WHITE]
PH: Pan head SUS: Stainless ZK: Black
MP4
MP9
[CTRL UNIT] REF. NO. J1
ORDER NO. 6510022440
DESCRIPTION Connector LTW-8MP-C
QTY.
W1
1
MP2
MP5 MP6
[MAIN UNIT] REF. NO. MP1
ORDER NO. 8510013150
DESCRIPTION 2345 VCO case
QTY. 1
7-1
1 1 2 2 2 2 2 1 2
MP41 (CH) MP40 (CH) MP22 (CH)
J2 (CH)
MP37 (CH)
MP27 (CH)
MP5 (CH) MP3 (CH)
MP2 (CH) W1 (CH) MP38 (CH)
MP29 (CH)
EP1 (CH) J1 (CT) MP45 (CH)
MP12 (CH) MP33 (CH)
MP46 (CH) MP31 (CH)
MP34 (CH) MP6 (CH) MP18 (CH)
PWR-CORD UNIT
MP30 (CH) J1 (CT)
MP35 (CH)
S1 (L) LOGIC UNIT
MP1 (M)
MP43 (CH)
CTRL UNIT
MP36 (CH) MP1 (L) EP1 (L)
MAIN UNIT MP3 (L)
MP44 (CH) DS1 (L) MP1 (CH) MP2 (L) MP47 (CH)
MP21 (CH)
SQL UNIT
VOL UNIT
DIAL UNIT
MP21 (CH)
MP9 (CH)
MP7 (CH)
Unit abbreviations (CH): CHASSIS PARTS (CT): CTRL UNIT (M): MAIN UNIT (L): LOGIC UNIT W1 (HM-126 CHASSIS) MP8 (CH)
7-2
7-2 HM-126
7-3 HM-127 (OPTIONAL UNIT)
[CHASSIS PARTS] REF. NO.
[MAIN UNIT]
ORDER NO.
DESCRIPTION
QTY.
W1
8900009770 8900009780
Cable OPC-948 Cable OPC-949
[BLACK] [WHITE]
1 1
MP1
8210016861 8210016961 8210016850 8210017110 8930052160 8930052150 8930052140 8930052690 8930052120 8930052110 8610010870 8310048760 8310048780 8820001150 8850001850 8930052340 8930052350 8930053870 8930053040 8850001610 8810009260 8810008900 8810009240 8930053850
2352 front panel-1 2352 front panel (A)-1 2352 rear panel 2352 rear panel (A) 2352 key 2352 PTT rubber 2352 PTT holder 2352 MIC rubber 2352 rubber 2352 main seal 2352 hanger knob 2352 R-plate 2352 MIC plate 2352 screw ICOM washer (Y) O-ring (AE) O-ring (AF) 2352 sheet (A) 2352 SP net Spring washer M4 SUS Screw PH BT 2 × 6 NI Screw PH M3 × 6 NI Screw M4 × 10 ZK 2352 SP rubber
[BLACK] [WHITE] [BLACK] [WHITE]
1 1 1 1 1 1 1 1 1 1 1 1 1 5 5 5 1 1 1 1 3 1 1 1
MP2 MP3 MP4 MP5 MP6 MP7 MP8 MP9 MP10 MP11 MP12 MP13 MP14 MP15 MP16 MP17 MP18 MP19 MP20 MP21 MP23
REF. NO.
ORDER NO.
[CHASSIS PARTS] DESCRIPTION
QTY.
MC1
7700002120
Microphone KUC2123-030245
1
SP1
2510001070
Speaker S36G04K-4
1
Screw abbreviations
BT: Self-Tapping NI: Nickel NI-ZU: Nickel-zinc
PH: Pan head SUS: Stainless ZK: Black
[MAIN UNIT]
ORDER NO.
REF. NO.
DESCRIPTION
W3
8900010220 8900010230
Cable OPC-997 Cable OPC-998
SP1
2510001090
Speaker 036D0801
MP1
8210017360 8210017390 8930053510 8930053540 8930053990 8930053550 8930053520 8930053760 8930039000 8810009180 8930053750 8210017250 8210017300 8310049970 8610010980 8930053740 8810008450 8850000490 8930053530 8820001180 8930053730
2417 front panel assembly 2417 front panel (A) assembly 2417 key board 2417 PTT rubber 2417 PTT sheet 2417 PTT holder 2417 top key 2417 key plate 1757 sheet Screw FT BT M2 × 5 NI-ZU 2417 plate 2417 rear panel 2417 rear panel (A) 2417 R-plate 2417 hanger knob O-ring (AJ) Screw M4 × 8 ZK Spring washer M4 SUS 2417 rubber 2417 screw 2.6 × 16 O-ring (AI)
MP3 MP4 MP5 MP6 MP7 MP8 MP10 MP11 MP12 MP13 MP14 MP15 MP16 MP17 MP18 MP19 MP20 MP21
QTY. [BLACK] [WHITE]
REF. NO.
1 1
ORDER NO.
DESCRIPTION
5030001900
LCD A0119 (LCD 36 × 28.5)
1
EP2
8930051120
LCD contact SRCN-2320-SP-N-W
2
MC1
7700002480
Microphone SKB-2746 LPC
1
MP1 MP2 MP3 MP4 MP5
8930053780 8210017240 8310050200 8930039610 8930054120
2417 LCD holder 2417 reflector 2417 H-plate Thermally sheet (C) Insulate sheet (J)
1 1 1 1 2
1 [BLACK] [WHITE]
[BLACK] [WHITE]
1 1 1 1 1 1 1 1 1 3 1 1 1 1 1 1 1 1 1 6 6
[UNPACKING] REF. NO.
ORDER NO.
DESCRIPTION
QTY.
W1
8900010280
Cable OPC-1000
1
MP1 MP2 MP3 MP4
8950005110 8810004700 8310050320 8810004700
2289 mic hanger Screw PH M3 × 16 SUS 2417 C-plate Screw PH M3 × 16 SUS
1 2 1 3
Screw abbreviations PH: Pan head BT: Self-tapping SUS: Stainless
FT: Flat head NI-ZU: Nickel-zinc ZK: Black
MP21 (CH)
MP15 (CH)
MP19 (CH)
MP20 (CH) MP15 (CH)
MP16 (CH)
MP9 (CH)
MP14 (CH)
MAIN UNIT
MP8 (CH)
QTY.
DS1
MP19 (CH)
SP1 (M) MC1 (M)
MP23 (CH)
MP18 (CH) MP12 (CH) MP13 (CH) MP14 (CH) MP2 (CH)
MP6 (CH) MP16 (CH)
MP18 (CH)
MAIN UNIT MP11 (CH)
MP21 (CH)
MP10 (CH) MP20 (CH)
MP3 (CH)
EP2 (M)
MP8 (CH)
MP17 (CH)
MP3 (M)
MP2 (M)
MP4 (M) MP13 (CH)
MP4 (CH) MP5 (CH)
MP4 (CH)
MP7 (CH) MP5 (M)
MP1 (CH)
MP12 (CH)
DS1 (M)
MP7 (CH)
MP1 (M) MP11 (CH)
SP1 (CH)
W3 (CH)
W1
MC1 (M)
MP3
W1 (CH)
HM-126 Unit abbreviations (CH): CHASSIS PARTS (M): MAIN UNIT
MP1
MP3 (CH) MP6 (CH) MP5 (CH)
MP2,4
MP10 (CH) MP1 (CH)
HM-127 UNPACKING 7-3
SECTION 8
SEMI-CONDUCTOR INFORMATION
• TRANSISTORS AND FET’S 2SA1576A T106R (Symbol: FR)
• DIODES
2SB1132 T100 R (Symbol: BARB)
2SB1143 S (Symbol: B1143)
2SC2714-Y (Symbol: QY)
1SS355 (Symbol: A)
2SC2954 T2B (Symbol: QK)
1SS375-TL (Symbol: FH)
DA204 U (Symbol: K)
DAN202 U (Symbol: N)
DAP202U (Symbol: P)
E
B
B
B
C
C
C
E
C
E E C
2SC3326 B (Symbol: CCB)
2SC3775-3-TB (Symbol: OY3)
B
2SJ144 Y (Symbol: VY)
S
G
D
3SK292 (Symbol: UK)
DTA144EUA T106 (Symbol: 16)
G2
S
G1
E
D
D
8-1
B C
C E
E
G1
DTC144EUA T106 (Symbol: 26)
B C
MA363 B (Symbol: 6D)
A
E
MA8062 M (Symbol: 6-2)
G2 C
S
DTC144 TU T107 (Symbol: 06)
B C
MA8043 L (Symbol: 4_3)
G
DTB123EK (Symbol: F12)
B
C
C
3SK166A-2-T7 (Symbol: K)
S
D
HSU88TRF (Symbol: 9)
E
2SK1069-4-TL (Symbol: FJ)
G
S
HSM88ASR TR (Symbol: C3)
B
E
S
D
G
A C2
A2
2SC4215 O (Symbol: QO)
C
2SK880 Y (Symbol: XY)
C1 C
E
B
E
2SK210 GR (Symbol: YG)
C
C
B
C
E
A
E
2SC4116 BL (Symbol: LL)
B C
E
D
2SC4081 T107 R (Symbol: BR)
B
C
A1
B
B
A
A
C
A
MA77 (Symbol: 4B)
C
A
MA8036 L (Symbol: 3_6)
C
C
A
BOARD LAYOUTS 9-3 SQL UNIT
9-1 VOL UNIT
J1 VOL1 VOL2 GND
J1
1 3 to MAIN unit W1
SQLG SQLV SQL5V
SECTION 9
1 3 to LOGIC unit J3
J2
DIALB GND NC DIALA
9-2 DIAL UNIT
1 4 to LOGIC unit J3
9-1
9-4 LOGIC UNIT • TOP VIEW
9-2
• BOTTOM VIEW
38
1 128
39
64
103 65
20
40
1
41
80
61
to HM-126 J2
1 J4
6
13
SP– SP– GND GND 8V MLDA HVS
KEYM GND
1 2 J1
SP+ SP+ +5V SRESET VPP LMDA HV
60
2
J3
1
DIALB GND DIALA SQLG SQLV +5V
21
102
to SQL and DIAL units
14 to MAIN unit J4 9-3
9-5 MAIN UNIT • TOP VIEW
75
51
76
14
1
50
1
16
8
9
J8 11
10
20
1
AFG AF
R304
2 10 for FLASH 9-4
5
9
5
8
1
W1
J3
to VOL unit J1
2 10 to optional unit UT-98 or UT-112
1
13
2 14 from CTRL unit J2
1
1 2 J2
to EXT-GPS
J4
13
2 14 from LOGIC unit J4
8 J7
1
SPMIC AF2 GND MIC MICE HANG PTT AF1
J6
4
4
HV LMDA VPP SRESET +5V SP+ SP+
1
9
8
VOL1 VOL2 GND
1
1
+5V GND OPTIN SCON GND GND GND
8
GND TMODE TRES SOT0 GND
J1
4
+5V TAUX3 P01 SIN0 SCK0
1
5
5
HVS MLDA 8V GND GND SP– SP–
25
4
SCK SDATA OPSTB MICI DETI MICO DETO
1
8
EXT SP
NMEAI+ NMEAI-
26
1
ICF3 MDDA MCDA +5V VCC SAFO SMIC
100
8
GND DMDA CMDA VCC DSCMOD GND MICG
7
2 1
to HM-126 J1
• BOTTOM VIEW
8
5
1
14
8
1
7
4
14
1
4
1
5
8
8
7
9-5
9-6 CTRL UNIT
9-9 HM-127 (OPTIONAL UNIT)
• TOP VIEW
• TOP VIEW
1
8
4
5
2
GND DMDA CMDA GND DSCMOD GND MICG
PWR/ICF3 MDDA MCDA +5V VCC SAFO SMIC
14 J2
13 1 to MAIN unit J3
9-7 PWR-CORD UNIT
9-8 HM-126
• TOP VIEW
• TOP VIEW to MAIN unit 1 4
J1 GND SPMIC MICE MIC PTT KGND KEYM
GND GND HV HV
J1
9-6
7
1
• BOTTOM VIEW (HM-127)
• BOTTOM VIEW (CTRL)
21
J1 PWRC 8 RRXDA RTXDA PTTC GND MICG AF/MIC 1 VCC
4
1
5
8
20
40
1
41
80
60
61
8
5
1
4
5
1
6
10
8
5
1
4
• BOTTOM VIEW (HM-126)
• BOTTOM VIEW (PWR-CORD)
to IC-M502 CTRL unit J1
9-7
SECTION 10
BLOCK DIAGRAM
FI3 ALFY450E
EXT.SP
OPTION
EXTERNAL SPEAKER
ATTA ATTB
IC1 TA31136FN IC4B NJM4558M
Q4 2SC2714
WX ALERT FM DET
MIC
HM-126 SPEAKER MIC
SP
DSC DEC
2nd IF AMP
FI1, FI2 FL-310
Q3 3SK166
IC4A NJM4558M
IC5 NJM2211M IC6 TC7W14FU
Q12 2SC2954
SP
VCC
T5
Q5 2SC4215
TMUT
Q10 2SC4215
Q17 DTC144EU
DIAL UNIT
AF VR
X1
DS1
Q9 2SC4215
SUB MPU
LCD DRIVER
RCV
RX-VCO IC1 µPD789405AGK-A30-9EU
IC2 HD66712SA03FS
Q22 2SB1132 Q23 DTC144EU
4.91 MHz SRESET
LCD CONT
VCC IC8 TA7808S
RL1 FTR-F3AA012E
D19 DSA3A1 REVERSE CONNECT PROTECT
T8 CTRL
R8
IC9 TA7805F
T8 A5V
VCC
Q32 2SC4116 D23 1SS355 RL2 FTR-F3AA012E
IC13B NJM4558M
IC13A NJM4558M
LOGIC UNIT HVS
RF MUTE
HV
IC14 LA4425A SP BEEPM Q5 DTA144EU Q6 DTC144EU
CLONE
R8 CTRL
HI/LO
TX-VCO
Q2 2SC4116 Q3 2SB1132 DS2–DS17 Q8 2SC4116 SML-311YT DIM CTRL
MAIN UNIT
8V Q20 2SB1132 Q21 DTC144EU
R8 T8
Q7 2SK210 D6–D8 MA363B
Q1, Q4 2SK1069
TX MUTE CTRL Q15 DTC144EU SEND
Q8 2SK210 D9, D10 MA363B
SQLV
Q26 2SJ144
Q37 DTC144TU Q35 DTA144EU Q36 DTC144TU D24 DA204U
IC15 S-80928ANMP
IC10 BU4066BCF
RESET Q27 2SJ144
Q24,25 2SC4116
IC12 BU4066BCF
X3 DMX-26S 32.768 kHz MIC AMP
MAIN MPU
IC11B NJM4558M
7.9872 MHz X4 CR-610
MIC AMP
IC16 MB90F583BPFV-G IC17 EEPROM HN58X2464TI
IC18 TC7W14FU Q40 2SK1069
IC11A NJM4558M
DSC Q33 2SK1069
PTTC/EXTRXD/EXTTXD
Q28 2SK1069
PWRC/ICF3
RMUTM
AF/MIC
RMUTS
OPTION
IC1 TC4W53F
SCRAM UNIT
OPTION
COMMON LINE LINE RX LINE
VCC
TX LINE
HM-127
DATA BUS LINE
CTRL UNIT
10 - 1
Q14 2SB1143 Q16 FMW1
21.25 MHz
IC2 µPD3140GS
VOL UNIT
TXDET
RF OUT DET
VCC
SQLI X2 CR-659
LOGIC UNIT
KEY BOARD
Q18 2SC4116 D14, D15 HSM88ASR
IC3 SC-1302
D11, D12 MA77
SQL
ENCODER
ANT D16, D17 XB15A308
1 stage
Q2 3SK292
Q11 2SC3775
2nd Lo BUFF
IC20 NJM2125F
D5V
ATT
2nd MIX
DSC DECODER
SQL UNIT
3 stage
Q31 DTC144EU Q32 2SC4116
13.8V
SECTION 11
VOLTAGE DIAGRAM
DTRS
LS0 LS1 LS2 LS3 LC2 LC3
COM15 COM14 COM13 COM12 COM11 COM10 COM9 SEG6 SEG7 SEG8 SEG9 SEG10 SEG16 SEG17 SEG18 SEG19 SEG20 SEG26 SEG27 SEG28 SEG29 SEG30 SEG36 SEG37 SEG38 SEG39 SEG40 SEG46 SEG47 SEG48 SEG49 SEG50 SEG56 SEG57 SEG58 SEG59 SEG60 COM1 COM2 COM3 COM4 COM5 COM6 COM7
11-1 LOGIC UNIT
DISTRESS
45 46 47 48 49 50 LS0 LS1 LS2 LS3 LC2 LC3
C15 C14 C13 C12 C11 C10 C9 S06 S07 S08 S09 S10 S16 S17 S18 S19 S20 S26 S27 S28 S29 S30 S36 S37 S38 S39 S40 S46 S47 S48 S49 S50 S56 S57 S58 S59 S60 C1 C2 C3 C4 C5 C6 C7
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44
DS16
DS15
DS1 TSD0393
DS11
DS9
DS12
DS7
DS10
SQL UNIT
DS2 SML-311YT
DS3–DS17 SML-311YT
J1 1 2 3
DSC SCAN
DS8
J3
CHWX
+5V SQLV SQLG DIALA GND DIALB
CH16 DS13
LS4 LS5 LS6 LS7 LC0 LC1
51 52 53 54 55 56 57 58 59 60 11 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94
CH/WX
16 R38 220
DS17 DS6
R43 220
R53 220
DS5
DS3
SQL5V SQLV SQLG DIALA GND DIALB
DIAL UNIT J2 1 2 3 4
DS4 D1 MA8043
POWER SW
LS4 LS5 LS6 LS7 LC0 LC1
COM17 COM18 COM19 COM20 COM21 COM22 COM23 SEG1 SEG2 SEG3 SEG4 SEG5 SEG11 SEG12 SEG13 SEG14 SEG15 SEG21 SEG22 SEG23 SEG24 SEG25 SEG31 SEG32 SEG33 SEG34 SEG35 SEG41 SEG42 SEG43 SEG44 SEG45 SEG51 SEG52 SEG53 SEG54 SEG55 COM31 COM30 COM29 COM28 COM27 COM26 COM25
SCAN
DSC
95 96 97 98 99 100
C17 C18 C19 C20 C21 C22 C23 S01 S02 S03 S04 S05 S11 S12 S13 S14 S15 S21 S22 S23 S24 S25 S31 S32 S33 S34 S35 S41 S42 S43 S44 S45 S51 S52 S53 S54 S55 C31 C30 C29 C28 C27 C26 C25
DS14
W1 1 2 3 4 5 6
1 2 3 4 5 6
R41 220
H/L
R42 220
R1
SQLG SQLV SQL5V
S1 DIALB GND DIALA
IC IC
LOGIC UNIT
HL HV S1 SPPH22014A
HVS
+5V
R47 10k
-1.89V
SEG18 SEG19 SEG20 SEG21 SEG22 SEG23 SEG24 SEG25 SEG26 SEG27 SEG28 SEG29 SEG30 SEG30 SEG32 SEG33 SEG34 SEG35 SEG36 SEG37 SEG38 SEG39 SEG40 SEG41 SEG42 SEG43
V5 V5OUT3 V5OUT2 GND C1 C2 VCI DB7 DB6 DB5 DB4 DB3 DB2 DB1 DB0/SOD E/SCLK RW/SID RS/CS GND TEST EXT IM RESET M D CL2
IC2 HD66712SA03FS
R28 10k
R27 10k
64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39
C22 1 DB7 DB6 DB5 DB4 DB3 DB2 DB1 DB0 E RW RS
E RW RS DB7 DB6 DB5 DB4 DB3 DB2 DB1 DB0 +5V
C23 0.01
R4 R64 10k 33k
C17 10
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
S10 S11 S12 S13 S14 S15 P93/S16 P92/S17 P91/S18 P90/S19 P87/S20 P86/S21 P85/S22 P84/S23 P83/S24 P82/S25 P81/S26 P80/S27 AVDD AVREF
C18 0.01
IC1 µPD789405AGK-A30-9EU
80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61
CONTDOT1 CONTDOT2 CONTDOT3 DIM1 DIM2 DIM3 +5V
SRXD STXD
DIALB DIALA
SQLV KEYM
COM25 COM26 COM27 COM28 COM29 COM30 COM31
C12 0.001
C11 10
8.02V
R68 10k
R11 20k
R12 10k
R13 18k
R14 10k
R15 20k
C16 0.01
R65 1M
C9 0.1
R10 10k
R9 NTCCM16084BH R67 18k
P40/KR0 P41/KR1 P42/KR2 P43/KR3 P44/KR4 P45/KR5 IC XT1 XT2 VDD0 VSS0 X1 X2 RESET P46 P47 P00 P01 P02 P03
7.95V
R8 10k
R6 12k
DIM4
8V
Q3 2SB1132 R69 39k
Q2 2SC4116 R70 47k
R16 10k
R55 10k
C13 0.01
R56 3.3k
Q8 2SC4116 R17 1k
X1 CSTCC4.91MG
DIM4 HL DSC IC DTRS
R22 10k 3.73V
4.93MHz 5.1Vp-p
C4 0.1
Q4 2SK1069 R18 100k R19 47k
41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60
R49 100k
C15 0.01
20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
C20 0.1
C3 0.1
R23 1.5k R24 10k
R20 22k
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 SEG44 SEG45 SEG46 SEG47 SEG48 SEG49 SEG50 SEG51 SEG52 SEG53 SEG54 SEG55 SEG56 SEG57 SEG58 SEG59 SEG60 COM9 COM10 COM11 COM12 COM13 COM14 COM15 J1 1 2
R3 47k
S9 S8 S7 S6 S5 S4 S3 S2 S1 S0 COM3 COM2 COM1 COM0 VSS1 VLC2 VLC1 VLC0 BIAS VDD1
C19 0.01
5.06V
R25 NTCCM16084BH
CONTSEG1
R26 10k
C6 C5 0.001 0.001
C14 0.1
SP+
CONTSEG2
SP–
C24 0.1
SQLV SCAN CHWX CH16
C1 0.001
DIALA
C2 0.001
DIALB
R33 R34 R35 R36 R37 100k 100k 100k 100k 100k
SP– SP+ SP– SP+ GND +5V GND SRESET 8V VPP MLDA LMDA HVS HV
KEYM C25 0.01
to Internal Speaker
R66 100k
R51 120k
to HM-126 J2
R2 10k
CONTSEG3 R50 390k
289kHz 4.9Vp-p
Q1 2SK1069 R7 1.5k
R1 47k
1.94V
P66/ANI6 P65/ANI5 P64/ANI4 P63/ANI3 P62/ANI2 P61/ANI1/CMPREF P60/ANI0/CMPIN0 AVSS P27/INTP3/CPT5 P26/INTP2/TO5 P25/INTP1/TI1 P24/INTP0/TI0 P23/CMPTOUT0/TO P22/SI/RXD P21/SO/TXD P20/SCK/ASCK P53 P52 P51 P50
C21 1
SEG17 SEG16 SEG15 SEG14 SEG13 SEG12 SEG11 SEG10 SEG9 SEG8 SEG7 SEG6 SEG5 SEG4 SEG3 SEG2 SEG1 COM0 COM1 COM2 COM3 COM4 COM5 COM6 COM7 COM8 COM17 COM18 COM19 COM20 COM21 COM22 COM23 COM24 V1 V2 V3 V4 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128
R29 10k
R5 47k
SEG44 SEG45 SEG46 SEG47 SEG48 SEG49 SEG50 SEG51 SEG52 SEG53 SEG54 SEG55 SEG56 SEG57 SEG58 SEG59 SEG60 COM9 COM10 COM11 COM12 COM13 COM14 COM15 COM16 COM25 COM26 COM27 COM28 COM29 COM30 COM31 COM32 COM33 VCC OSC2 OSC1 CL1
SEG18 SEG19 SEG20 SEG21 SEG22 SEG23 SEG24 SEG25 SEG26 SEG27 SEG28 SEG29 SEG30 SEG31 SEG32 SEG33 SEG34 SEG35 SEG36 SEG37 SEG38 SEG39 SEG40 SEG41 SEG42 SEG43
R48 10k
LS7 LS6 LS5 LS4 LS3 LS2 LS1 LS0 LC3 LC2 LC1 LC0
R46 27k
COM17 COM18 COM19 COM20 COM21 COM22 COM23
COM1 COM2 COM3 COM4 COM5 COM6 COM7
R30 10k R45 10k
102 101 100 99 98 97 96 95 94 93 92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65
SEG17 SEG16 SEG15 SEG14 SEG13 SEG12 SEG11 SEG10 SEG9 SEG8 SEG7 SEG6 SEG5 SEG4 SEG3 SEG2 SEG1
R44 10k
+5V
+5V
R52 10k
VPP SRESET LMDA
Q5 R32 DTA144EU 10k
HVS HV R31 10k C7 0.01
Q6 DTC144EU
11 - 1
C8 0.01
J4 1 2 3 4 5 6 7 8 9 10 11 12 13 14
to MAIN unit J4
11-2 MAIN UNIT MAIN UNIT
VCC
VCC
TMODE TAUX3
VCC 8V +5V
TMODE TAUX3
MAIN (1)
VCC 8V +5V T8 R8 DEMOD
VCC 8V +5V T8 R8 DEMOD BUS LINE
PLL BUS OPT BUS MAIN BUS R199 100k
SP HI/LO SEND Q34 DTA144EU
C292 0.22
L9 3.3µ
Q7 2SK210
C290 C291 0.5p 0.5p
L10 LB-258
C300 0.001
C314 10
Q33 2SK1069 DSC
C301 0.1
D9 R257 MA363B 1k
BE
L12 3.9µ
L13 LB-257
C288 4p L11 C289 2.7µ 3p Q45 2SC4116 R276 47
Q8 2SK210
R212 2.7k
C296 0.047
C286 0.1
C305 0.22
C298 2p C299 4p
L14 2.7µ
C49 0.1
SQLI
C31 47p Q3 3SK166
C34 0.001
C38 0.001
c
R21 FI1 1.2k FL-310
IC1 TA31136FN
R241 180
2
FI3 ALFY450E 1
MAIN (2)
L7 56n
C47 0.001
5 4 3
C312 0.01
FI2 FL-310
C274 0.001
Q4 2SC2714
L34 1µ
C46 39p
L30 0.15µ
C45 39p
R18 CP1 10k
R250 47
R261 4.7k D29 1SS355
C304 0.22
R8
R63 2.2k
C102 0.001
C103 0.001
R56 680
C318 10
RX : 3.03V TX : 0V
4
R292 120k
RX : 0V TX : 7.95V RX : 0.3V TX : 13.2V
3
C331 0.01
R291 47k
5
1
2
C335 0.01
IC21 NJM2125F
T8
R59 C96 3.3k 0.001
C100 0.001
L16 0.1µ
C101 12p
C97 0.01
L15 0.1µ
VGG D12 MA77
R65 2.2k R64 39
C98 12p
R57 100
R60 2.2k
R61 220
L17 82n
R71 1k
C111 0.001
L18 82n
R72 100
C108 0.001
R68 10k
R73 10
C114 0.001
C115 6.8
C116 22p
L19 47n
L20 47n
C117 18p Q12 2SC2954
C118 39p
C119 18p
PI
C112 1p C109 18p Q11 2SC3775
R66 390 R62 C104 1k 0.001
R70 10
C105 0.001 R67 10k C106 47p
Q10 2SC4215
R55 68k Q9 2SC4215
d VCC T8
R290 27k
D11 MA77
R58 100
C278 0.001
C302 0.75p R258 1k
C59 0.1
C60 0.001
C64 220p
C62 1
R31 820
R42 47k
R259 10
R270 5.6k
R20 2.2k
R19 10
C36 6p
8V T8 R8 VCC R33 20k
R251 82
R262 2.2k
9 10 11 12 13 14 15 16 AFOUT QUAD IFOUT RSSI N_DET N_REC GND MIXIN FILIN FILOUT DEC IFIN VCC MIXOUT OSCOUT OSCIN 8 7 6 5 4 3 2 1
C70 10p
C71 12p
C63 220p
C32 0.022
C40 0.001
C110 0.001
C113 0.001
R209 1k
1 2 3 4
R29 1.5k
R32 33k
C33 0.001 R22 1.5k
R74 1k
MICDSC
C285 0.001
R8 R23 100k
C42 0.022
R75 10
C255 0.1
A0 A1 A2 VSS
C53 100p
R27 1.2k
R25 3.3k C43 0.001
R30 330k
Q44 2SC4116 R249 33k
R304 330
C107 0.001
D6 R252 MA363B 4.7k
C259 0.1 BAND EXTENTION
C69 18p
C72 0.001
R248 47k
R208 100k
IC17 HN58X2464TI
D5 MA8036
R283 NTCCM16084LH
C283 0.001
R211 56k
C56 10
R289 3.3k
Q6 2SK880
R44 10k C295 0.047
LBAT SQL RTXD RRXD
C256 10
VCC GND SCL SDA
R256 18k
C293 0.1 CP2
+5V
R227 15k
D13 1SS355
D10 MA363B HVS HV +5V
D24 DA204U
HVS HV +5V
Q37 DTC144TU
/TMUT R218 R219 R220 R221 R222
R253 8.2k
C74 0.001
C54 47p
C58 0.001
X2 CR-659
R43 1k
R255 1k
C57 0.01
Q5 2SC4215 R41 330
C294 2.2
R210 1M
8 7 6 5
R254 560
C55 0.01
C66 5p
C67 20p
R37 100
C77 0.001
BPLVLM
PTTM PTTS MMUTE SMUTE
C81 0.01
UNLK DSDEC TXDET WXDEC
C257 0.1
R225 47k
OPSTB PSTB CK DATA
MMUTE SMUTE SP HI/LO SEND TMUT SRXD STXD TCK CLRX CLTX
STRU SCON
R205 47k
R203 100k
P22/A18 P23/A19 P24/A20 P25/A21 P26/A22 P27/A23 P30/ALB P31/RDK VSS P32/WRLX P33/WRHX P34/HRQ P35/HAKX P36/RDY P37/CLK P40/SIN0 P41/SOT0 P42/SCK0 P43/SIN1 P44/SOT1 VCC P45/SCK1 P46/ADTG P47 C
STRU SCON
OPSTB PSTB CK DATA PTTM PTTS
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25
R194 100k
C254 0.01
C65 0.001
R35 68k
L8 0.1µ
R38 68
C48 0.22
21.7MHz
C39 0.01
R69 100
P01 SRESET
IC16 MB90587CA-107
50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26
R8
C99 0.001
ATT1 ATT2
R202 100k
HSTK MD2 MD1 MD0 P81/IRQ1 P80/IRQ0 P57/AN7 P56/AN6/SCK4 P55/AN5/SOT4 P54/AN4/SIN4 VSS P53/AN3 P52/AN2/SCK3 P51/AN1/SOT3 P50/AN0/SIN3 AVSS AVRL AVRH AVCC P74/DA01 P73/DA00 DVSS DVRH P72 P71
C68 0.001
C50 0.001
R28 X1 390 CDBCA450CX24
R36 680
C303 0.001 R39 100
20 19 18 17 16 15 14 13 12 11
C287 7p
R193 27k
R201 100k
GND1 IN2 VCC2 XB XI XO GND2 CP2 FI2 FO2
C297 1p
R191 R192 100k 2.7k
C253 0.1
C252 24p R190 10
PA2 X1A X0A VSS X0 X1 VCC P00/AD00 P01/AD01 P02/AD02 P03/AD03 P04/AD04 P05/AD05 P06/AD06 P07/AD07 P10/AD08 P11/AD09 P12/AD10 P13/AD11 P14/AD12 P15/AD13 P16/AD14 P17/AD15 P20/A16 P21/A17
PSTB CK DATA UNLK
VCC1 IN1 ENB CLK DATA T1 LOK CP1 FI1 FO1
D7 MA363B C284 1p
R189 1M
DATAS R204 150k
21.25MHz
IC2 µPD3140GS 1 2 3 4 5 6 7 8 9 10
D8 MA363B
76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100
R246 100k R45 1k
VCC 8V +5V
C251 X4 24p CR-610
C79 0.022
MDDA
75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51
R188 47k
4.71V
R40 47
R26 470
C51 0.001
C52 0.1
ATTB ATTA OPTIN HANG PTT BE
DATAM DATAS
R226 47k
R305 47k
ATT1 R200 100k
RSTX PA1 PA0 P97/POT P96/PWC P95/TOT2/OUT1 P94/TOT1/OUT0 P93/TOT0/IN3 P92/TIN2/IN2 P91/TIN1/IN1 P90/TIN0/IN0 RX* TX* P65/CKOT P64/PPG0 P63/PPG1 P62/SCK2 P61/SOT2 P60/SIN2 P87/IRQ7 P86/IRQ6 P85/IRQ5 P84/IRQ4 P83/IRQ3 P82/IRQ2
FLASH BUS
R186 100k
BEEPM
RMUTS RMUTM RCV R185 100k
IC15 S-80928ANMP OUT CD 5 VDD VSS NC 4
R184 100k
RESET 1 2 3 R183 39k
C248 0.027
R182 39k
SQLI
CP3 Q42 DTA144EU ATT2
Q41 DTA144EU
MLDA
10k 100k 100k 100k 100k
C258 0.1
R223 100k
Q35 DTA144EU
MAIN BUS
R228 1k
R229 1k
OPT BUS SMIC SAFO +5V MOD SPSP+
CLTX LMDA
CLRX
R224 100k
RRXD ICF3
Q36 DTC144TU
SMIC SAFO +5V MOD SPSP+
UART BUS
+5V TAUX3 P01 SIN0 SCK0
TAUX3 P01
for FLASH J1 1 2 3 4 5 6 7 8 9 10
GND TMODE TRES SOT0 GND
D26 HSU88
R233 1k Q40 2SK1069 R234 47k
D28 DAP202U
RTXD CMDA +5V IC18 TC7W14FU 1 8 2 7 3 6 4 5
C306 0.1
R235 1k
Q38 2SC4081 MCDA
IC19 TLP121
R237 470 EXT-GPS
from LOGIC unit J4
J2 NMEAI+ 1 NMEAI2 J4 1 2 3 4 5 6 7 8 9 10 11 12 13 14
HV HVS LMDA MLDA VPP 8V SRESET GND +5V GND SP+ SPSP+ SP-
D27 1SS355
R236 6.8k
R1 100k
C262 0.1
R230 4.7k
ICF3
ICF3 GND MDDA DMDA MCDA CMDA +5V VCC VCC DSCMOD SAFO GND SMIC MICG
MDDA DATAS MCDA CMDA
R231 Q39 47 2SA1576
C263 0.0047 R240 100k
R239 100k
J3 1 2 3 4 5 6 7 8 9 10 11 12 13 14
W3
J2 14 13 12 11 10 9 8 7 6 5 4 3 2 1
PWRC/ICF3 GND MDDA DMDA MCDA CMDA +5V VCC VCC DSCMOD SAFO GND SMIC MICG
R2 100k
2.46V
R3 1M
C14 0.01
R5 1M
1 2 3 4
C12 1
R6 100k
IC1 TC4W53F
C10 10
R4 1M C11 1
4.95V
8 7 6 5
EXTMIC PTT ON :0V EXTMIC PTT OFF:4.95V
D5V SMIC SAFO PTTC
PWRC/ICF3
R238 100k RESET TMODE
C13 1
13.2V
C7 0.01
J1 EXTRXD EXTTXD
MLDA LMDA
PTTC
SRESET
D4 MA8062
C15 0.01
7 6
VCC
1 8
5 4 3
2 AF/MIC MICG
GND
C9 0.01
CTRL UNIT
11 - 2
MAIN (2) VCC 8V +5V T8 R8 DEMOD BUS LINE
C124 1
R77 5.6k
Q15 DTC144EU
4
L24 LA-243
L25 LA-253
C137 5p
C136 12p
5
R84 RV-143
R80 150
Q17 DTC144EU
8 7 6 5
ATTA L31 1µ
VCC
8V
DEMOD R8 +5V
DSDEC
R277 2.2k
WXDEC
C160 0.1
2
R107 100k
R110 RV-148
C164 0.01
R111 330 C165 470p
4
PWR-CORD BOARD 13.8V
HV
R112 10k ANT
C138 27p
C171 C172 10 0.1
Q22 2SB1132
Q21 DTC144EU
C176 0.1
Q23 DTC144EU
R120 560k
R122 2.7k
R124 33k
R118 C183 C184 8.2k 0.027 0.027
Q25 2SC4116 R125 33k
Q24 2SC4116 R123 330
R127 100k
R126 2.2k
C186 820p
C192 R130 1 100k
C190 0.0039 Q27 2SJ144
C189 1
C246 0.22
HVS HV +5V
C326 0.01
C195 0.01
C194 0.1
Q28 2SK1069
R131 100k
C191 0.0039
C196 0.1
R133 100k 1 2 3 4 5 6 7
C197 0.001
R134 1k
TP96N97-15F10KA-2345
VCC 5V VOL1 VBIAS
C193 1
R129 470k
C327 0.001
VOLR1 UNIT
C178 0.01
R128 470k
C188 10
C185 0.0022
R121 180k
C182 0.22
C2 0.001 C1 0.001
C177 0.1
Q26 2SJ144
R119 8.2k
HV HV HV GND GND
RL1 FTR-F3AA012E
IC9 TA7805F
C175 10
R117 1k
R8
4 3 2 1
8.04V C167 0.001
R115 2.2k
R116 47
Q18 2SC4116
C173 C174 0.1 10
HV HV GND GND
4.95V
R114 10k C166 0.001
R113 2.2k
C179 470
VCC IC8 TA7808S
Q20 2SB1132
+5V
HI/LO
HVS HV +5V
8 3
C163 0.0022 IC6 TC7W14FU 1 2 3 4
R108 39k
IC4A NJM4558M
C131 0.001
R86 1M
R85 22k
R87 100k
C152 C157 0.01 0.047
R109 15k
J1
D15 HSM88ASR
R83 10k
C125 0.01
3 R79 10k R78 3.3k
/TMUT
HVS HV +5V
1
C126 0.001
2
L27 LA-238
C128 18p C134 8p
C130 0.001
D14 HSM88ASR
Q16 FMW1
C142 27p L23 LA-149
R100 470k
HV HVS VCC 8V +5V +5V R8
C139 4p
R82 2.2k
C129 0.001
PI Q14 2SB1143 R76 47k
R81 2.2k
C127 24p
C143 100p
C141 33p C133 0.001
R99 1.5k
RCV
D17 XB15A308
L26 LA-243
R98 8.2k
R101 470k
R106 47k
C161 0.033 14 13 12 11 C162 0.1 10 9 8
W1 VOL1 VOL2 GND R135 1M
IC10 BU4066BCF I/O VDD O/I CONT.A O/I CONT.D I/O I/O CONT.B O/I CONT.C O/I VEE I/O
R136 1M
14 13 12 11 10 9 8
C200 0.1
1 2 3
J1 1 2 3
1 2 3
VOL1 VOL2 GND
C202 47p
MMIC C198 0.1
W2 GND
to LOGIC C199 0.1
SMIC
PTTM MMUTE MICAF
P0 C123 0.001
VGG
VDD
PI
L21 LA-243
C120 220
VGG
C132 0.001
3 4
C3 0.3p
D33 1SS375
D16 XB15A308
L22 LW-25
C151 0.01
C159 0.22
V+ CAP CAP IN LOCK R GND LOOP REF Q Q NC DATA FSK
D19 DSA3A1
R88 150
C150 0.01
R97 10k
C2 10p
3.48V
VCC T8
2
R2 220k
C149 0.01
R105 470k
1
C6 0.001
C15 0.001
IC3 SC-1302
1
R6 47k
C8 470p
D36 D2 1SV214 1SV214
C19 0.001
C25 0.001
C11 0.001
L1 LS-440
CP4
C155 0.033
C154 0.033
INCOM
D3 1SV214
C12 470p
C156 470p
R132 100k
R11 R10 220k 220k
C330 0.001
R297 1k d VCC T8
R9 100
IC5 NJM2211M 1 2 3 4 5 6 7
6
SMUTE PTTS
R288 10k
C14 15p
C153 0.012
R96 100k
C4 15p
R4 22k
IC4B NJM4558M
5
D18 1SS355
MAIN (1)
D4 1SV214
Q2 3SK292
C13 1.5p
R104 10k
R103 10k
RMUTM RMUTS
R12 220k
C18 15p
C20 2p
C332 1p
R287 1
C16 3p
R3 33k C5 2p
R5 10k
C1 18p
C317 10
T8
C24 15p C23 2p
R16 10k
C17 0.001
L3 LS-440
C9 0.001
R102 10k
C158 0.1
7
C148 0.1
RCV
L4 LS-440
c
C10 0.001
TXDET
C28 10p
R8 470
C21 0.5p
C22 2p
C7 0.001
R7 100
R95 100k
DEMOD C275 0.001
D35 1SV214
L33 10µ
L2 LS-440
D34 1SV214
C26 0.01
CHASSIS J2
4.66V R90 47
HVS HV +5V DEMOD R8 +5V SEND
R8 C27 0.001
ATTB R278 2.2k
C309 0.22
A5V
D31 R1 MA77 39
R267 10k
L32 1µ
2
C316 0.001
3 C307 0.22
R265 10k
W5
D32 R242 C276 MA77 22 0.001
W6
C315 0.001
CP5
D1 1SV214
R268 1k
C1 1p
4
C308 0.1 R266 1k
SQL
R263 10k SQLI
R264 10k
W2
ANT IC20 NJM2125F 5 1
MAIN BUS DSC
MAIN BUS
OPT BUS
OPT BUS SMIC SAFO +5V
SMIC SAFO 5V
6
R172 RV-110 C229 47p
R170 12k
C228 0.0027
C231 0.01
1 2 3 4 5 6 7
R165 150k R167 82k
R166 82k C226 0.0039
IC13A 8 NJM4558M 1 R164 100k C225 0.001
3
R161 12k
2
C223 0.1 C219 0.1
4 C224 22p
C227 82p
C319 0.1
VDD I/O O/I CONT.A CONT.D O/I I/O I/O O/I CONT.B CONT.C O/I VEE I/O
R152 1M
8 IC11A R151 NJM4558M 1M 1
R148 18k 3
R296 10k
R295 10k
2 R147 1.2k C215 470p
4
MICDSC
C214 0.033
IC11B NJM4558M 5 7 6 C213 47p
BPLVLM BEEPM R177 15k
SP-
R179 1M C238 0.01 R180 22k
Q31 DTC144EU R178 1.2k
DATA OPTIN OPSTB SCON
C212 0.22
C203 0.1
C239 1
C240 1 C241 0.001
C242 IC14 0.1 LA4425A 5 1 4 2 3
RL2 FTR-F3AA012E
C243 470 R260 18k C244 470
D23 1SS355 Q32 2SC4116
R181 4.7
R137 2.7k
J6 CK
R143 15k
C204 0.1
R247 22k
C328 0.1
R142 1M
R144 18k
VOL2 VCC MICO MICI DETO DETI 5V +5V
Vcc D22 DA204U
R284 100k
R285 100k
VBIAS
+5V
4.95V
R286 100k
R145 1M
R149 39k
R157 56
R163 1M
R281 820
C333 1
C217 0.01
R150 18k
C218 0.1
IC12 BU4066BCF
C334 0.1
R153 47k Q29 DTC144EU
14 13 12 11 10 9 8
D37 DAP202U
MICAF
SP
C279 0.001
R171 12k
IC13B NJM4558M 5 7
R160 1M
R154 1M
DETI DETO MICI MICO
C282 0.1
R168 10k
R162 82k
R156 1M
STRU
R169 NTCCM16084BH
R173 18k
C232 10
MOD
VBIAS
2.68V
R294 100k
2.68V R155 1M
Q46 2SJ144
R280 10k
SMIC SAFO 5V
R175 8.2k
C235 10
R174 33k
C236 0.1
C234 0.01
R176 47
C233 0.1
SMIC SAFO +5V MOD SPSP+
AF AF1
C337 10
R298 10k
D38 DAP202U RMUTM
J7
R140 100
HANG
PTTM
HANDSET
R299 10k Q47 2SC3326 R300 10k
D21 DA204U
D20 DA204U
Optional unit UT-98 or UT-112
C205 0.1
R141 1k
PTT
+5V SCK GND SDATA OPTIN OPSTB SCON MICI GND DETI GND MICO GND DETO
C209 0.01
C208 470p
C207 0.001
AF1 PTT HANG MICE MIC GND AF2 SPMIC
1 2 3 4 5 6 7 8
SP/MIC
C206 47p
C245 0.1 R301 330
R302 330
J8
R303 330
C321 47p
AF AFG
SP+ C210 470p
11 - 3
1 2
EXT SP
GND
11-3 HM-127 (OPTIONAL UNIT) MAIN UNIT CHASSIS
C10 0.1
UP
HL
SCAN
PWRSW
CP2 SP+
C12 1
R35 1k
IC2 TA7368F 1 2 3 4 5
S5 R37 22k 10KEY
R36 10k
SEG21 SEG17 SEG13 COM3 COM2 COM1 COM0 SEG0 SEG1 SEG2 SEG3 SEG4 SEG5 SEG6 SEG7 SEG8 SEG9 SEG10 SEG11 SEG15 SEG19
S10 SQL DS7 SML-311YT
DS4 SML-311YT S1
S2
DS8 SML-311YT
S3
10KEY
C14 0.1
C13 0.047
C11 0.1
NC VCC NC VIN RIPPLE
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21
SKQLLC
SKQLLC
Q4 2SJ144
C24 1
DOWN
SEG21 SEG17 SEG13 COM3 COM2 COM1 COM0 SEG0 SEG1 SEG2 SEG3 SEG4 SEG5 SEG6 SEG7 SEG8 SEG9 SEG10 SEG11 SEG15 SEG19
DS10 SML-311YT
VRDAT
R3 150
10KEY
IC SEG25 SEG23 SEG24 SEG20 SEG16 SEG12 SEG13 SEG14 SEG15 SEG17 SEG18 SEG19 SEG21 SEG22 SEG23 SEG25 SEG26 SEG27
DS9 SML-311YT
VIN1 VOUT1 GND DATA
R70 33
VRCK
R43 2.7K ERJ3GE
SEG9 SEG8 SEG7 SEG6 SEG5 SEG4 SEG3 SEG2 SEG1 SEG0 COM3 COM2 COM1 COM0
R9 10k R20 6.8k
20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
R22 20k
S9 S8 S7 S6 S5 S4 S3 S2 S1 S0 COM3 COM2 COM1 COM0 VSS1 VLC2 VLC1 VLC0 BIAS VDD1
R24 1.2k
P66/ANI6 P65/ANI5 P64/ANI4 P63/ANI3 P62/ANI2 P61/ANI1/CMPREF P60/ANI0/CMPIN0 AVSS P27/INTP3/CPT5 P26/INTP2/TO5 P25/INTP1/TI1 P24/INTP0/TI0 P23/CMPTOUT0/TO P22/SI/RXD P21/SO/TXD P20/SCK/ASCK P53 P52 P51 P50
R77 22 C7 0.1
VCCSW DIM1 DIM2 DIM3
R27 10k
DIM4
C54 1
5V
VCC
C34 0.1
C36 0.1
IC6 TA7808F
R61 39k
R28 20k
R60 10k
R30 18k
R29 10k
R32 20k
R31 10k
C40 0.1
WDSW MODE DOWN UP BEEP STXD SRXD BPLVL
C41 330
C51 47p
D2 DAN202U
R62 47k R34 1k
CONT2
PTT
R69 100
CP18
RMUTE
RMUTE
BEEP
BEEP
CP16 PTT
IC7 S-80928ANMP 1 2 3
R50 100k
DOWN
OUT VDD VSS
CD NC
5 4
R51 27k C42 0.027
RTXDA
RESET PWR PTT
SCAN CHWX CH16
R16 100k
CP14
CONT3
UP
R15 100k
C52 47p
R64 3.9k R52 39k
PWR
R17 100k
R18 100k
5V
PTT
R53 100k
C44 0.1
C45 0.01
Q9 2SK1069
VCCSW
R56 1k
VPP 5V
5V
J2 VPP 5V RESET TXD RXD GND
C50 0.001
VCC
C39 100
C38 0.1
R68 100
RESET SRXD
SRXD
STXD
STXD
11 - 4
VCC AF/MIC MICG GND PTTC RTXDA RRXDA PWRC
Q12 2SC4116
PWR
1 2 3 4 5 6
D3 1SS355
Q3 2SC4116
CONT1
R14 100k R12 100k
C47 470P
CP11
8V
R63 10k
R33 10k
R13 100k R11 100k
8 7 6 5
J1
41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60
R10 100k
IC9 TC4W53FU 1 2 3 4
CP15
C6 0.01 R59 15k
C53 0.01
R67 1M
CP12
C9 0.01
R26 NTCCM16084BH
HL VOL IC SQL
C35 22
IC5 TA78L05F
R25 10k
R23 10k VRDAT VRCK
X1 CSTCC4.91MG
R66 1M
R76 22 Q2 2SB1132
R19 1M
R45 100k
AF5V C37 22
R75 22
Q1 2SK1069
IC4 NJM2125F
2
C30 10
5V
C5 0.01
IC1 µPD789405AGK-A30-9EU
CP6
R65 1M
4 1
Q6 DTB123EK
R8 10k
5
3
C28 0.1
P40/KR0 P41/KR1 P42/KR2 P43/KR3 P44/KR4 P45/KR5 IC XT1 XT2 VDD0 VSS0 X1 X2 RESET P46 P47 P00 P01 P02 P03
C33 1
R44 100k
C29 0.001
Q5 DTC144EU
PTT
R21 39k
C3 22
R47 470k
R46 33k
CH16
SEG24 SEG20 SEG16 SEG12 SEG13 SEG14 SEG15 SEG17 SEG18 SEG19 SEG21 SEG22 SEG23 SEG25 SEG26 SEG27
PTT R7 10k
C4 0.01
C31 0.22
C32 47p
CP7 R6 10k
80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61
MC1 SKB-2746 LPC
MICG
C27 470p
CP4 C22 0.01
R38 15k
10KEY SKQLLC
S10 S11 S12 S13 S14 S15 P93/S16 P92/S17 P91/S18 P90/S19 P87/S20 P86/S21 P85/S22 P84/S23 P83/S24 P82/S25 P81/S26 P80/S27 AVDD AVREF
MIC R42 12k
S7
C1 10
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
R41 100k C25 0.01 CP5
D1 DA204U
CHWX
S4
SEG10 SEG11 SEG12 SEG13 SEG14 SEG15 SEG16 SEG17 SEG18 SEG19 SEG20 SEG21 SEG22 SEG23 SEG24 SEG25 SEG26 SEG27
R39 100k
C23 22
10KEY
DS2 FY1101F-TR
R40 470k
8 7 6 5
VIN2 VOUT2 VCC CLK
C26 1
10KEY S9
DS5 FY1101F-TR
39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22
1 2 3 4
S11
DS3 FY1101F-TR
CP3 C17 100
IC3 M62429FP
S6
DS1 A0119
SP1 036D0801 -
S8
SKQLLC
DS6 FY1101F-TR
SP-
C16 100
VOL
R2 120
+
C18 330
10 9 8 7 6
C15 100
10KEY R1 120
POUT PWGND PREGND PHASE NF
1 2 3 4
Q10 2SC4081 R57 4.7k
8 7 6 5 IC8 TC7W14FU
C46 0.1
RRXDA R58 47
R54 1k
R55 47k
Q11 2SA1576
CP17
1 2 3 4 5 6 7 8
11-4 HM-126 MC1 KUC2123-030245
W1
R1 12k
C2 470p
C1 470p
W2 SP1 S36G04K-4
R5
W3 W4
PTT
15
UP-ON 2.0V DN-ON 3.0V H/L-ON 3.8V
KEYM KGND PTT MIC MICE SPMIC GND
W1 (CHASSIS) J1 1 2 3 4 5 6 7
P3 1 2 3 4 5 6 7
KEYM KGND PTT MIC MICE SPMIC GND
GREEN BROWN RED IN OUT WHITE BLACK
GREEN BROWN
KEYM KGND
P2 1 2
RED BLUE OUT IN BLACK
AF1 PTT HANG MICE MIC GND AF2 SPMIC
P1 1 2 3 4 5 6 7 8
S1 SKHHLP014A HANG S2
R2
6.8k
BLUE
WHITE
UP S3
R3
15k
S4
R4
33k
to LOGIC unit J1 (IC-M501EURO)
to MAIN unit J7 (IC-M501EURO)
DN
H/L S2–S4 : SKHHAM024A
11 - 5
1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan Phone : 06 6793 5302 Fax : 06 6793 0013 URL : http://www.icom.co.jp/world/index.html
Icom America Inc.
Icom (Europe) GmbH
< Corporate Headquarters >
Communication Equipment Himmelgeister Str. 100, D-40225 Düsseldorf, Germany Phone : 0211 346047 Fax : 0211 333639 URL : http://www.icomeurope.com
2380 116th Avenue N.E., Bellevue, WA 98004, U.S.A. Phone : (425) 454-8155 Fax : (425) 454-1509 URL : http://www.icomamerica.com < Customer Service > Phone : (425) 454-7619
Icom Canada Glenwood Centre #150-6165 Highway 17 Delta, B.C., V4K 5B8, Canada Phone : (604) 952-4266 Fax : (604) 952-0090 URL : http://www.icomcanada.com
Icom (Australia) Pty. Ltd. A.B.N. 88 006 092 575 290-294 Albert Street, Brunswick, Victoria, 3056, Australia Phone : 03 9387 0666 Fax : 03 9387 0022 URL : http://www.icom.net.au
Icom New Zealand 146A Harris Road, East Tamaki, Auckland, New Zealand Phone : 09 274 4062 Fax : 09 274 4708
Asia Icom Inc. 6F No. 68, Sec. 1 Cheng-Teh Road, Taipei, Taiwan, R.O.C. Phone : (02) 2559 1899 Fax : (02) 2559 1874
Icom Spain S.L Crta. de Gracia a Manresa Km. 14,750 08190 Sant Cugat del Valles Barcelona, SPAIN Phone : (93) 590 26 70 Fax : (93) 589 04 46 URL : http://www.icomspain.com
Icom (UK) Ltd. Unit 9, Sea St., Herne Bay, Kent, CT6 8LD, U.K. Phone : 01227 741741 Fax : 01227 741742 URL : http://www.icomuk.co.uk
Icom France S.a Zac de la Plaine, Rue Brindejonc des Moulinais BP 5804, 31505 Toulouse Cedex, France Phone : 561 36 03 03 Fax : 561 36 03 00 URL : http://www.icom-france.com
1-1-32, Kamiminami, Hirano-ku Osaka 547-0003, Japan
S-13710HZ-CD © 2000 Icom Inc.
View more...
Comments
