Icom IC-4008A-MK2 Service Manual
December 10, 2017 | Author: Yayok S. Anggoro | Category: N/A
Short Description
Download Icom IC-4008A-MK2 Service Manual...
Description
SERVICE MANUAL UHF FM TRANSCEIVER LPD FM TRANSCEIVER
INTRODUCTION This service manual describes the latest service information for the at the time of publication. MODEL IC-4008MK IC-4008A
VERSION Italy C.S.America
SYMBOL ITA ITA-1 CSA CSA-1
BODY COLOR BLACK YELLOW BLACK YELLOW
To upgrade quality, all electrical or mechanical parts and internal circuits are subject to change without notice or obligation.
DANGER NEVER connect the transceiver to an AC outlet or to a DC power supply that uses more than 5 V. Such a connection could cause a fire hazard and/or electric. DO NOT expose the transceiver to rain, snow or any liquids. DO NOT reverse the polarities of the power supply when connecting the transceiver. DO NOT apply an RF signal of more than 20 dBm (100mW) to the antenna connector. This could damage the transceiver's front end.
ORDERING PARTS Be sure to include the following four points when ordering replacement parts: 1. 2. 3. 4.
10-digit order numbers Component part number and name Equipment model name and unit name Quantity required
0910049951 PCB B-5109B IC-4008A MAIN UNIT 5 pieces 8810009780 Screw PH BO M2x6 ZK IC-4008A Chassis 10 pieces
Addresses are provided on the inside back cover for your convenience.
REPAIR NOTES 1. 2. 3. 4. 5. 6. 7.
Make sure a problem is internal before disassembling the transceiver. DO NOT open the transceiver until the transceiver is disconnected from its power source. DO NOT force any of the variable components. Turn them slowly and smoothly. DO NOT short any circuits or electronic parts. An insulated turning tool MUST be used for all adjustments. DO NOT keep power ON for a long time when the transceiver is defective. DO NOT transmit power into a signal generator or a sweep generator. ALWAYS connect a 30 dB to 40 dB attenuator between the transceiver and a deviation meter or spectrum analyzer when using such test equipment. 8. READ the instructions of test equipment thoroughly before connecting equipment to the transceiver.
TABLE OF CONTENTS
SECTION
1
SPECIFICATIONS
SECTION
2
INSIDE VIEWS
SECTION
3
DISASEMBLY INSTRUCTION
SECTION
4
CIRCUIT DESCRIPTION
SECTION
4-1
RECEIVER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-1
4-2
TRANSMITER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-2
4-3
PLL CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-2
4-4
POWER SUPPLY CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-3
4-5
PORT ALLOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-3
5
ADJUSTMENT PROCEDURES
5-1
PREPARATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-1
5-2
ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-2
SECTION
6
PARTS LIST
SECTION
7
MECHANICAL PARTS AND DISASSEMBLY
7-1
CABINET PARTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7-1
7-2
ACCESSORIES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7-1
SECTION
8
SEMI-CONDUCTOR INFORMATION
SECTION
9
BOARD LAYOUTS
9-1
MAIN UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9-1
9-2
RF UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9-5
SECTION
10 BLOCK DIAGRAM
SECTION
11
VOLTAGE DIAGRAM
11-1
MAIN UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11-1
11-2
RF UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11-2
SECTION 1
SPECIFICATIONS [ITA], [ITA-1]
Number of channels
69 channel (simplex; 433.075–434.775)
Type of emission
16K0F3E
GENERAL
Frequency stability
Current drain
25 kHz 3 × AA(R6) dry, alkaline;or optional BP-202 less than 140 mA
–10˚C to +55˚C (–14˚F to +122˚F)
Number of CTCSS frequency
38 (67.0–250.3 Hz)
Dimensions (proj. not included)
55.5(W) × 102.5(H) × 26.5(D) mm 23⁄16(W) × 41⁄32(H) × 11⁄32(D) inch
Weight (included 3 cells)
180 g; 7.8 oz
Modulation system
10 mW
500 mW
Variable reactance frequency modulation
Max. freqequency deviation Spurious emissions
±5.0 kHz –40 dB 50 µW
0.25 µW
Adjacent channel power
more than 47 dB
External mic.connector
3-conductor 2.5(d) mm/2.2 kΩ
Receiving system
Double conversion superheterodyne 1st: 21.7 MHz 2nd: 450 kHz
Intermediate frequency
RECEIVER
less than 500 mA
Operating temperature range
Output power
TRANSMITTER
±2500 Hz (±5.7 ppm)
Frequency resolution Power supply requirements (negative ground)
[CSA], [CSA-1]
Sensitivity (12 dB SINAD)
0.2 µV ;–14 dBµ
Adjacent channel selectivity
more than 40 dB
Spurious response
more than 40 dB
Intermoduration
more than 40 dB
Audio output power External SP connector
100 mW at 10% distortion with an 8 Ω load 2-conductor 3.5 (d) mm (1⁄8")/8 Ω
All stated specifications are subject to change without notice or obligation.
1-1
CHANNEL FREQUENCY LIST Channel No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23
Frequency (MHz) 433.0750 433.1000 433.1250 433.1500 433.1750 433.2000 433.2250 433.2500 433.2750 433.3000 433.3250 433.3500 433.3750 433.4000 433.4250 433.4500 433.4750 433.5000 433.5250 433.5500 433.5750 433.6000 433.6250
Channel No. 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46
Frequency (MHz) 433.6500 433.6750 433.7000 433.7250 433.7500 433.7750 433.8000 433.8250 433.8500 433.8750 433.9000 433.9250 433.9500 433.9750 434.0000 434.0250 434.0500 434.0750 434.1000 434.1250 434.1500 434.1750 434.2000
Channel No. 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69
Frequency (MHz) 434.2250 434.2500 434.2750 434.3000 434.3250 434.3500 434.3750 434.4000 434.4250 434.4500 434.4750 434.5000 434.5250 434.5500 434.5750 434.6000 434.6250 434.6500 434.6750 434.7000 434.7250 434.7500 434.7750
Channel No. 14 15 16 17 18 19 20 21 22 23 24 25 26
Frequency (Hz) 107.2 110.9 114.8 118.8 123.0 127.3 131.8 136.5 141.3 146.2 151.4 156.7 162.2
Channel No. 27 28 29 30 31 32 33 34 35 36 37 38 ---
Frequency (Hz) 167.9 173.8 179.9 186.2 192.8 203.5 210.7 218.1 225.7 233.6 241.8 250.3 OFF
CTCSS FREQUENCY LIST Channel No. 1 2 3 4 5 6 7 8 9 10 11 12 13
Frequency (Hz) 67.0 71.9 74.4 77.0 79.7 82.5 85.4 88.5 91.5 94.8 97.4 100.0 103.5
1-2
SECTION 2
INSIDE VIEWS
• MAIN UNIT TOP VEIW
BOTTOM VEIW
Audio amplifier (IC9: NJM2070M) EEPROM (IC3: X24C01AS)
T+3 Regurator (Q28: 2SB798) +3 Regurator (IC6: S-81230SG)
CPU (IC1: µPD753036GK)
R+3 Regurator (Q18: 2SA1586)
• RF UNIT TOP VIEW
1st mixer (Q2: 2SC4226)
BOTTOM VIEW
Reference oscilletor (X1: CR-633 21.25 MHz) PLL IC (IC1: TB31202FN)
FM IF IC (IC2: TA31136FN) 1st IF filter (Fl2: FL-298)
VCO circuit
1st IF amplifier (Q1: 2SC4215)
RF amplifier (Q3: 2SC5194)
2nd IF filter (Fl3: CFWM450E)
2-1
SECTION 3
DISASEMBLY INSTRUCTIONS • REMOVING THE MAIN UNIT
• REMOVING THE REAR PANEL Unscrew 1 screw
, and 4 screws
Unscrew 2 screws,
.
.
Remove the PTT rubber,
Remove the rear panel in the direction of the arrow.
Unsolder 2 points,
F
B
.
, and remove the MAIN unit.
G
B
A H
• REMOVING THE RF UNIT Remove 1 knob, Unsolder 1 point,
, and unscrew 1 nut,
.
, and then remove the RF unit.
RF unit C
E D
MAIN unit
3-1
SECTION 4
CIRCUIT DESCRIPTION
4-1-1 ANTENNA SWITCHING CIRCUIT (RF UNIT)
4-1-4 2nd MIXER AND DEMODULATOR CIRCUITS (RF UNIT)
Received signals from the antenna connector are passed through the low-pass filter (L5, L6, C8–C12). The filtered signals are applied to the λ⁄4 type antenna switching circuit (D7, D101, D102, L4, L206, C209, C210).
The 2nd mixer circuit converts the 1st IF signal to a 2nd IF signal. A double conversion superheterodyne system (which converts receive signals twice) improves the image rejection ratio and obtains stable receiver gain.
The antenna switching circuit functions as a low-pass filter while receiving. However, its impedance becomes very high while D101 and D102 are turned ON (while transmitting). Thus transmit signals are blocked from entering the receiver circuits. The passed signals are then applied to the RF amplifier circuit.
The 1st IF signal from the IF amplifier (Q1) is applied to the 2nd mixer section in the FM IF IC (IC2, pin 16), and is mixed with the 2nd LO signal to be converted into a 450 kHz 2nd IF signal.
4-1 RECEIVER CIRCUITS
The FM IF IC contains a 2nd mixer, quadrature detector, noise amplifier and a limiter amplifier, etc. The PLL reference oscillator (X1) is used for the 2nd LO signal via the PLL IC (IC1, pins 11, 9), and is applied to pin 1 of the FM IF IC (IC2).
4-1-2 RF CIRCUIT (RF UNIT) The RF circuit amplifies signals within the range of frequency coverage and filters out-of-band signals. The signals from the antenna switching circuit are amplified at the RF amplifier (Q3) and passed through the bandpass filter (FI1) to suppress out-of-band signals. The filtered signals are applied to the 1st mixer circuit (Q2).
The mixed 2nd IF signal is output from pin 3 and passed through the ceramic bandpass filter (FI3) to remove unwanted heterodyne frequencies. It is then amplified at the limiter amplifier section (IC2, pin 5) and applied to the quadrature detector section (IC2, pins 10, 11) to demodulate the 2nd IF signal into AF signals.
4-1-3 1st MIXER AND 1st IF CIRCUITS (RF UNIT)
4-1-5 AF CIRCUIT (RF AND MAIN UNITS) AF signals from the FM IF IC (RF unit; IC2, pin 9) are passed through the high-pass filter (RF unit; Q15, Q16) to remove CTCSS signals then applied to the MAIN unit via J2 pin 10 as the “VOL” signal.
The 1st mixer circuit converts the received signals to a fixed frequency of the 1st IF signal with a PLL output frequency. By changing the PLL frequency, only desired signals will be passed through a crystal filter at the next stage of the 1st mixer.
The “VOL” signal (AF signals) from the RF unit is applied to the [VOL] control (MAIN unit; R58) to control the audio level via the volume mute switch (Q23). The level controlled AF signals are applied to the AF power amplifier (IC9, pin 2) to drive an internal speaker (SP1) via the [SP] jack (J1).
The signals from the bandpass filter are mixed at the 1st mixer circuit (Q2) with a 1st LO signal coming from the VCO circuit to produce a 21.7 MHz 1st IF signal.The 1st IF signal is applied to a crystal filter (FI2) to suppress out-of-band signals. The filtered 1st IF signal is applied to the IF amplifier (Q1), then applied to the 2nd mixer circuit (IC2, pin 16).
• 2nd IF AND DEMODULATOR CIRCUITS 2nd IF filter 450 kHz C75
C74 R51 7
8 R53 C76
5
Active filter
PLL IC IC1 11
Mixer
Limiter amp.
9
10
11
14
R58 R57
C78 R+3 X2
4-1
X1 21.25 MHz
16
IC2 TA31136FN
1st IF (21.7 MHz) from Q1 "SQL" signal to the CPU pin 59
C77 C67
1
9
Noise detector
FM detector
AF signal "AF"
3
RSSI
R52
(21.25 MHz)
FI3
4-1-6 SQUELCH CIRCUIT (RF AND MAIN UNITS)
4-2-3 DRIVE/POWER AMPLIFIER CIRCUITS (RF UNIT)
(1) NOISE SQUELCH The noise squelch circuit cuts out AF signals when no RF signals are received. By detecting noise components in the AF signals, the squelch circuit switches the AF mute switch.
The amplifier circuit amplifies the VCO oscillating signal to the output power level. The amplified transmit signal is passed through the antenna switching circuit (D6) and low-pass filter, and is then applied to the antenna.
A portion of the AF signals from the FM IF IC (RF unit; IC2, pin 9) are applied to the active filter section (RF unit; IC2, pin 8). The active filter section amplifies and filters noise components. The filtered signals are applied to the noise detector section and output from pin 14 as the “SQL” signal.
The modulated transmit signal is amplified at the pre-drive and drive amplifiers (Q8, Q201) after being amplified at the buffer amplifier (Q7). The amplified signal is power amplified at the power amplifier (Q202) to obtain 500 mW or (IC–4008A) 10 mW (IC–4008MK2) of RF power.
The “SQL” signal from IC2 (pin 14) passes through J2 pin 9, and is then applied to the CPU (MAIN unit; IC1, pin 59). The CPU analyzes the noise condition and outputs the “RMUT” and “AFON” signals to toggle the volume mute (MAIN unit; Q23) and AF mute (MAIN unit; Q5, Q10, Q11) switches.
The power amplified signal is then applied to the antenna via the low-pass filter circuits.
(2) TONE SQUELCH The tone squelch circuit detects AF signals and opens the squelch only when receiving a signal containing a matching subaudible tone (CTCSS). When tone squelch is in use, and a signal with a mismatched or no subaudible tone is received, the tone squelch circuit mutes the AF signals even when noise squelch is open.
4-3 PLL CIRCUITS (RF UNIT) A PLL circuit provides stable oscillation of the transmit frequency and receive 1st LO frequency. The PLL output compares the phase of the divided VCO frequency to the reference frequency. The PLL output frequency is controlled by the divided ratio (N-data) of a programmable divider.
A portion of the AF signals from the FM IF IC (RF unit; IC2, pin 9) passes through the tone low-pass filter (MAIN unit; Q7, Q12) to remove AF (voice) signals and is applied to the CTCSS decoder inside the CPU (MAIN unit; IC1, pin 58) via the “CTCIN” line to control the volume mute and AF mute switches.
The PLL circuit consists of the VCO circuit (Q6, D4, D5). An oscillated signal from the VCO passes through the buffer amplifier (Q7) is applied to the PLL IC (IC1, pin16) and is prescaled in the PLL IC based on the divided ratio (N-data). The reference signal is generated at the reference oscillator (X1) and is also applied to the PLL IC. The PLL IC detects the out-of-step phase using the reference frequency and outputs it from pin 14. The output signal is passed through the loop filter (R45, C68) and is then applied to the VCO circuit as the lock voltage.
4-2 TRANSMITTER CIRCUITS 4-2-1 MICROPHONE AMPLIFIER CIRCUIT (MAIN UNIT)
If the oscillated signal drifts, its phase changes from that of the reference frequency, causing a lock voltage change to compensate for the drift in the oscillated frequency.
AF signals from the internal/external microphone are applied to the microphone amplifier circuit (IC2b) via the microphone switch (Q6). The amplified signals are passed through the low-pass filter (IC2a) and applied to the modulation circuit in the RF unit via J4 pin 5 as the MOD signal.
4-2-2 MODULATION CIRCUIT (RF UNIT) The filtered audio signals from J4, pin 5 (On the MAIN unit) are passed through the deviation adjustment pot (R50) then applied to the modulation circuit (D4, D5) to modulate transmit signals at the VCO circuit (Q6). The modulated signal is applied to the drive amplifier circuit. • PLL circuit
D2
VCO
D1
Buffer
to transmitter circuit to 1st mixer circuit
Q7 Loop filter
Q6, D4, D5 IC1 (PLL IC) 14
to the FM IF IC (IC2, pin 1) X1 21.25 MHz
Phase detector
Programmable counter
Prescaler
9 11
Programmable divider
Shift register
4-2
16 6 7 8
CK DATA STB
4-4 POWER SUPPLY CIRCUITS VOLTAGE LINE LINE BATT
3V
DESCRIPTION
Common 3 V converted from the BATT line at the 3V regulator circuit (IC6). The circuit outputs the voltage regardless of the power ON/OFF condition. Common 3 V converted from the BATT line at the +3V regulator circuit (Q25, D4).
R+3
Receive 3 V cotrolled by the R+3 regulator circuit (Q18) using the “RXV” signal from CPU (IC1).
T+3
Transmit 3 V converted from the BATT line at the T+3 regulator circuit (Q27, Q28, D5, etc.) using the “TXV” signal coming from CPU (IC1).
Port name PTT2
PTT1
Input port for the PTT switch from the external mic jack (MAIN unit; J1). Low : External PTT switch is ON. Input port for the internal PTT switch. Low : While PTT switch is pushed.
36
UP
37
MODE
Input port for the [MODE] switch.
38
POWSW
Input port for the POWER switch. Low : While POWER switch is pushed.
48
49
50
Outputs data signals to the PLL IC (RF unit; IC1).
52
PLLST
Outputs strobe signals for the PLL IC (RF unit; IC1).
UNLK BEEP
Outputs control signal for the +3V regPOWER ulator circuit (MAIN unit; Q25, D4). CTCO0– Output port for the CTCSS signals. CTCO2
57
Outputs control signal for the MIC amplifier (IC2). TXMOD Low : While microphone amplifier is ON.
58
CTCIN
Input port for the CTCSS decode signals.
59
SQLIN
Input port for squelch level signal.
60
REMIN
Input ports for the control signal from the external remote microphone.
61
BATIN
Input port form the connected battery pack for low battery indication.
62
SENIN
Input port for the RSSI signal from the FM IF IC (RF unit; IC2) to detect receiving signal strength level.
73
Outputs clock signal to the EEPROM EEPCK (IC3).
74
Outputs data signals to the EEPROM EEPDA (IC3).
Input port for the [DOWN] switch.
DOWN
46
PLLDA
Description
35
45
51
54–56
4-5-1 CPU (MAIN unit; IC1)
34
Description
53
4-5 PORT ALLOCATIONS
31
Port name
The voltage from the connected battery pack.
+3V
Pin number
Pin number
Input port for the [UP] switch.
Input port for PLL unlock signal from the PLL IC (RF unit; IC1). Low : During unlock.
75
PSC
Output port for power save function, applied to VCO regurator circuit (RF unit; Q13, Q14, D8, D9).
76
RXV
Outputs the R+3 regulator control signal (Q18).
77
TXV
Outputs the T+3 regulator control signal (Q27, Q28, D5, etc.).
78
Outputs control signal for LCD backLAMPC light. Low : While LCD backlight is ON.
79
Outputs internal microphone control signal. MICSW High : While internal PTT switch is pushed.
80
Outputs MIC mute signal for RING function. MMUTE High : While RING signals are output, etc.
Outputs beep audio signal.
Outputs volume mute switch (Q23) RMUTE control signal. High : While squelched AFON
Outputs control signal for the AF amplifier regulator circuit (Q5, Q10, Q11). High: When squelch is open.
PLLCK
Outputs clock signal to the PLL IC (RF unit; IC1).
4-3
SECTION 5
ADJUSTMENT PROCEDURES
5-1 PREPARATION REQUIRED TEST EQUIPMENT EQUIPMENT
GRADE AND RANGE
EQUIPMENT
DC power supply
Output voltage Current capacity
: 4.5 V DC : 1 A or more
RF power meter (terminated type)
Measuring range Frequency range Impedance SWR
: : : :
Frequency counter
Frequency range : 0.1–600 MHz Frequency accuracy : ±1 ppm or better Sensitivity : 100 mV or better
FM deviation meter
Frequency range Measuring range
DC voltmeter
Input impedance
GRADE AND RANGE Frequency range Measuring range
: 300–3000 Hz : 1–500 mV
Frequency range Output level
: 0.1–600 MHz : 0.1 µV–32 mV (–127 to –17 dBm)
Oscilloscope
Frequency range Measuring range
: DC–20 MHz : 0.01–10 V
AC millivoltmeter
Measuring range
: 10 mV–10 V
: 30–600 MHz : 0 to ±10 kHz
External speaker
Input impedance Capacity
:8Ω : 300 mW or more
: 50 kΩ/V DC or better
Attenuator
Power attenuation Capacity
: 30 or 40 dB : 1 W or more
Audio generator
1 mW–1 W 300–600 MHz 50 Ω Less than 1.2 : 1
Standard signal generator (SSG)
ENTERING THE ADJUSTMENT MODE Turn the transceiver power OFF. While connecting the “TEST” on the RF board to “GND”, then turn power ON. (See location at page 5-3)
CONNECTIONS
CAUTION: DO NOT transmit while SSG is connected to the antenna connector.
FM deviation meter
Attenuator 30 dB or 40 dB
Standard signal generator –17 to –125 dBm (32 mV to 0.1 µV)
RF power meter 50 Ω / 1–500 mW
Frequency counter
to the RF test port J1 DC power supply – + 4.5 V /1.0 A
5-1
5-2 ADJUSTMENT ADJUSTMENT
MEASUREMENT
ADJUSTMENT CONDITION
REFERENCE 1 • Operating channel : Ch 35 FREQUENCY • Transmitting
VALUE
ADJUSTMENT POINT
UNIT LOCATION UNIT Top Loosely couple a fre- 433.925000 MHz RF panel quency counter to the antenna.
ADJUST C63
OUTPUT POWER
1 • Operating channel : Ch 35 • Transmitting
RF
Connect an RF power 9 mW [ITA/–1] meter to the RF test 470 mW [CSA/–1] port J1.
RF
R206
FM DEVIATION
1 • Operating channel : Ch 01 • Connect an audio generator to the [MIC] jack and set as: 1 kHz/100 mV rms • Set an FM deviation meter as: HPF : OFF LPF : 20 kHz or 15 kHz De-emphasis : OFF Detector : (P–P)/2 • Set group No. : 01 • Transmitting
RF
Connect an FM devia- ±4.8 kHz tion meter to the RF test port J1.
RF
R50
: OFF (– –) 2 • Set group No. • Set an audio generator output level until the deviation is ±3.5 kHz. • Transmitting SQUELCH
10 mV ±3 dB
Front Push panel and hold [MODE] and [DOWN]
Front Internal speaker 1 • Operating channel : Ch 35 • Connect an SSG to J1 on the RF unit panel and set as: Level : 0.14 µV* (–124 dBm) Modulation : OFF • Receiving 2 • Set an SSG as Level • Receiving
: : OFF
Audio signal disappears.
5-2
Verify
Verify
C63 Reference frequency adjustment
R50 FM deviati
R206 Output power adjustment
J1 RF GND RF test por TEST
ENTERING THE ADJUSTMENT MODE q Turn the transceiver power OFF. w While connecting the "TEST" to GND, then turn power ON.
5-3
SECTION 6
PARTS LIST [MAIN UNIT]
[MAIN UNIT] REF NO.
ORDER NO.
DESCRIPTION
IC1 IC2 IC3 IC5 IC6 IC9
1140006881 1110002820 1140004450 1110004710 1180001150 1110002810
S.IC S.IC S.IC S.IC S.IC S.IC
µPD753036GK-524-BE9 NJM2100M-T1 X24C01AS-3.0T6 S-80928ANMP-DDR-T2 S-81230SG-QB-T1 NJM2070M-T1
Q1 Q2 Q3 Q5 Q6 Q7 Q10 Q11 Q12 Q14 Q18 Q23 Q25 Q27 Q28 Q29 Q101
1590000720 1590001860 1590000800 1510000580 1560000840 1530002280 1530002280 1530003090 1530002280 1590001330 1510000770 1590001390 1590002490 1530002280 1520000200 1590000680 1590002630
S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.FET S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.FET S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR
DTA144EUA T106 UN9215 (TX) UN5119 (TX) 2SA1362-GR (TE85R) 2SK1829 (TE85R) 2SC4081 T107 S 2SC4081 T107 S 2SC4213-B (TE85R) 2SC4081 T107 S DTA114EUA T106 2SA1586-GR (TE85R) 2SJ144-Y (TE85R) UMZ2N TR 2SC4081 T107 S 2SB798-T2 DK DTC114EUA T106 UMZ1N TR [CSA], [CSA-1] only
D2 D4 D5
D303
1750000550 1750000550 1750000550 1790001250 1750000550 1790001250 1790001250
S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE
1SS355 TE-17 1SS355 TE-17 1SS355 TE-17 [CSA], [CSA-1] MA2S111-(TX) [ITA], [ITA-1] 1SS355 TE-17 [CSA], [CSA-1] MA2S111-(TX) [ITA], [ITA-1] MA2S111-(TX) [ITA], [ITA-1] only
X1
6050010450 S.XTAL
CR-627 (5.8368 MHz)
R2 R4 R5 R6 R7 R9 R10 R12 R13 R14 R22 R23 R24 R25 R26 R27 R30 R31 R32 R33 R34 R35 R36 R37 R38 R39 R40 R41 R42 R43 R45 R46 R49 R50 R51
7030003670 7030003670 7030003810 7030003710 7030003450 7030003680 7030003310 7030003200 7030003520 7030003500 7030003620 7030003580 7030003820 7030003570 7030003560 7030003320 7030003660 7030003800 7030003780 7030003540 7030003540 7030003530 7030003560 7030003600 7030003600 7030003670 7030003640 7030003520 7030003510 7030003650 7030003840 7030003320 7030003320 7030003520 7030003760
ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ
D101
S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR
823 823 125 184 122 104 820 100 472 332 333 153 155 123 103 101 683 105 684 682 682 562 103 223 223 823 473 472 392 563 225 101 101 472 474
V V V V V V V V V V V V V V V V V V V V V V V V V V V V V V V V V V V
(82 kΩ) (82 kΩ) (1.2 MΩ) (180 kΩ) (1.2 kΩ) (100 kΩ) (82 Ω) (10 Ω) (4.7 kΩ) (3.3 kΩ) (33 kΩ) (15 kΩ) (1.5 MΩ) (12 kΩ) (10 kΩ) (100 Ω) (68 kΩ) (1 MΩ) (680 kΩ) (6.8 kΩ) (6.8 kΩ) (5.6 kΩ) (10 kΩ) (22 kΩ) (22 kΩ) (82 kΩ) (47 kΩ) (4.7 kΩ) (3.9 kΩ) (56 kΩ) (2.2 MΩ) (100 Ω) (100 Ω) (4.7 kΩ) (470 kΩ)
REF NO.
ORDER NO.
R52 R53 R54 R55 R56 R57 R58 R60 R61 R62 R63 R64 R65 R66 R67 R68 R69 R70 R71 R72 R74 R76 R77 R78 R79 R80 R81 R86 R87 R88 R89 R90 R94 R95 R96 R97 R98 R99 R100 R101 R102 R103 R105 R106 R108 R110 R112
7030003740 7030003820 7030003450 7030003330 7030004050 7030003580 7210001970 7030003680 7030003280 7030003680 7030003530 7030003590 7030003590 7030003590 7030003590 7030003590 7030003590 7030003660 7030003620 7030003800 7030003560 7030003680 7030003400 7030003560 7030003720 7030003680 7030003560 7030003680 7030003800 7030003680 7030003440 7030003440 7030003720 7030003520 7030003680 7030003680 7030003680 7030003680 7030003680 7030003680 7030003680 7030003680 7030003560 7030003560 7030003620 7030003800 7030003560
DESCRIPTION S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR VARIABLE S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR
7030003620 S.RESISTOR R114
7030003450 S.RESISTOR 7030003500 S.RESISTOR
R115
7030003410 S.RESISTOR
R118 R119
7030003520 S.RESISTOR 7030003680 S.RESISTOR
R200
7030003840 S.RESISTOR
R201
7030003370 S.RESISTOR
R202 R301
7030003320 S.RESISTOR 7030003590 S.RESISTOR
R302
7030003440 S.RESISTOR
C1 C3 C4 C5 C6 C7
4030009980 4030011600 4030011600 4030006850 4030008680 4030011600
S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC
ERJ3GEYJ 334 V (330 kΩ) ERJ3GEYJ 155 V (1.5 MΩ) ERJ3GEYJ 122 V (1.2 kΩ) ERJ3GEYJ 121 V (120 Ω) ERJ3GEYJ 1R0 V (1 Ω) ERJ3GEYJ 153 V (15 kΩ) RV-244 (RK0971110) 10KA ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 470 V (47 Ω) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 562 V (5.6 kΩ) ERJ3GEYJ 183 V (18 kΩ) ERJ3GEYJ 183 V (18 kΩ) ERJ3GEYJ 183 V (18 kΩ) ERJ3GEYJ 183 V (18 kΩ) ERJ3GEYJ 183 V (18 kΩ) ERJ3GEYJ 183 V (18 kΩ) ERJ3GEYJ 683 V (68 kΩ) ERJ3GEYJ 333 V (33 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 471 V (470 Ω) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 224 V (220 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 224 V (220 kΩ) ERJ3GEYJ 472 V (4.7 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 333 V (33 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 103 V (10 kΩ) [CSA], [CSA-1] ERJ3GEYJ 333 V (33 kΩ) [ITA], [ITA-1] ERJ3GEYJ 122 V (1.2 kΩ) [ITA], [ITA-1] ERJ3GEYJ 332 V (3.3 kΩ) [CSA], [CSA-1] ERJ3GEYJ 561 V (560 Ω) [CSA], [CSA-1] ERJ3GEYJ 472 V (4.7 kΩ) ERJ3GEYJ 104 V (100 kΩ) [CSA], [CSA-1] only ERJ3GEYJ 225 V (2.2 MΩ) [CSA], [CSA-1] only ERJ3GEYJ 271 V (270 Ω) [CSA], [CSA-1] only ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 183 V (18 kΩ) [ITA], [ITA-1] only ERJ3GEYJ 102 V (1 kΩ) [ITA], [ITA-1] only
C1608 C1608 C1608 C1608 C2012 C1608
JB 1H 152K-T-A JB 1C 104KT-N JB 1C 104KT-N JB 1H 471K-T-A JF 1C 105Z-T-A JB 1C 104KT-N
S.=Surface mount 6-1
[MAIN UNIT] REF NO.
[MAIN UNIT]
ORDER NO.
REF NO.
DESCRIPTION
C8 C9 C10 C11 C15 C17 C18 C20 C21 C24 C25 C26 C27 C28 C29 C31 C32 C34 C35 C36 C40 C42 C44 C45 C46 C47 C48 C49 C50 C51 C52 C53 C54 C55 C56 C57 C59 C60 C61 C62 C63 C64 C65 C67 C71 C72 C73 C74 C75 C79 C80 C81 C82 C83 C85 C86 C87 C88 C89 C90 C91 C92 C93 C94 C95 C96 C97 C98
4510004630 4030006850 4030006850 4030006850 4030011600 4550006880 4510004630 4030011600 4030011600 4030008900 4030006850 4030006850 4030011600 4030008920 4030011280 4030008880 4030011600 4030006880 4030011600 4030006860 4030011600 4030006900 4030011600 4030009650 4030009650 4030006850 4510005430 4030011600 4030011600 4030011600 4510005860 4030011600 4030011600 4510005870 4030011600 4030011600 4030006850 4030011600 4030011600 4030011600 4030011600 4510005430 4030011600 4030009590 4030011600 4030006900 4030008650 4030006860 4030006860 4030011600 4510005900 4030008900 4030008920 4030011600 4030011600 4030009590 4030006850 4030006850 4030006850 4030006850 4030006850 4030006850 4030010760 4030010760 4030010760 4030010760 4030010760 4030010760
S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC
ECEV1CA100SR C1608 JB 1H 471K-T-A C1608 JB 1H 471K-T-A C1608 JB 1H 471K-T-A C1608 JB 1C 104KT-N TEMSVD2 0J 157M-12R ECEV1CA100SR C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1C 333K-T-A C1608 JB 1H 471K-T-A C1608 JB 1H 471K-T-A C1608 JB 1C 104KT-N C1608 JB 1C 473K-T-A C1608 CH 1H 271J-T-A C1608 JB 1C 223K-T-A C1608 JB 1C 104KT-N C1608 JB 1H 472K-T-A C1608 JB 1C 104KT-N C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A C1608 JB 1C 104KT-N C1608 CH 1H 240J-T-A C1608 CH 1H 240J-T-A C1608 JB 1H 471K-T-A ECEV0JA220SR C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N ECEV1HA2R2SR C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N ECEV1HA3R3SR C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1H 471K-T-A C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N ECEV0JA220SR C1608 JB 1C 104KT-N C2012 JF 1C 225Z-T-A C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A C1608 JB 1H 332K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N ECEV0GA101SR C1608 JB 1C 333K-T-A C1608 JB 1C 473K-T-A C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C2012 JF 1C 225Z-T-A C1608 JB 1H 471K-T-A C1608 JB 1H 471K-T-A C1608 JB 1H 471K-T-A C1608 JB 1H 471K-T-A C1608 JB 1H 471K-T-A C1608 JB 1H 471K-T-A C1608 CH 1H 331J-T-A C1608 CH 1H 331J-T-A C1608 CH 1H 331J-T-A C1608 CH 1H 331J-T-A C1608 CH 1H 331J-T-A C1608 CH 1H 331J-T-A
J1 J3 J4
6450000130 CONNECTOR 6450001060 CONNECTOR 6510017950 S.CONNECTOR
HSJ1102-01-540 HSJ1493-01-010 4-175638-4
DS1 DS2
5010000120 S.LED 5030001580 LCD
LN1371G-(TR) LD-BU10185J (E-10185-1)
MC1
7700002160 MICROPHON
KUC3523-040245
S1
2260001900 SWITCH
SW-149
ORDER NO.
DESCRIPTION
W1 W3 W4 W5 W6 W7
7030003860 7030003860 7030003860 9001502002 7120000470 7030003860
S.JUMPER S.JUMPER S.JUMPER WIRE JUMPER S.JUMPER
EP1 EP2
8930045510 LCD CONTACT 0910050341 PCB 0910050792 PCB
ERJ3GE JPW V ERJ3GE JPW V ERJ3GE JPW V 72/98/030/X98/X98 ERDS2T0 ERJ3GE JPW V
SRCN-2045-SP-N-W B 5161A [ITA], [ITA-1] B 5109B [CSA], [CSA-1]
[RF BOARD] REF NO.
ORDER NO.
DESCRIPTION
IC1 IC2
1110004150 S.IC 1110003200 S.IC
TB31202FN (ER) TA31136FN (EL)
Q1 Q2 Q3 Q6 Q7 Q8 Q12 Q13 Q14 Q15 Q16 Q201 Q202
1530002600 1530002920 1530003620 1530003320 1530003320 1530002940 1530003260 1530002280 1510000770 1530002280 1530002280 1530000372 1590002600
S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.FET
2SC4215-O (TE85R) 2SC4226-T2 R25 2SC5194-T1 2SC5108-Y (TE85R) 2SC5108-Y (TE85R) 2SC4228-T2 R44 2SC5006-T1 2SC4081 T107 S 2SA1586-GR (TE85R) 2SC4081 T107 S 2SC4081 T107 S 2SC3356 R24-T2B MRF9745 T1
D1 D2 D4 D5 D7 D8 D9 D101 D102 D103
1790000620 1790000620 1720000640 1720000640 1790001260 1750000550 1750000550 1790001260 1790001260 1790001240
S.DIODE S.DIODE S.VARICAP S.VARICAP S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE
MA77 (TX) MA77 (TX) 1SV284 (TPH3) 1SV284 (TPH3) MA2S077-(TX) 1SS355 TE-17 1SS355 TE-17 MA2S077-(TX) MA2S077-(TX) MA2S728-(TX)
FI1 FI2 FI3
2040001330 S.SAW 2010002330 MONOLITH 2020001270 CERAMIC
X1 X2
6050010480 S.XTAL CR-633 (21.250 MHz) 6070000210 S.DISCRIMINATOR CDBCA450CX24
L1 L3 L4 L5 L6 L10 L11 L12 L13 L14 L15 L19 L21 L23 L25 L105 L201 L202 L203 L204 L205
6200002240 6200004380 6200005670 6200008270 6200008270 6200005700 6200003640 6200003640 6200002350 6200005720 6200007000 6200005710 6200005700 6200008430 6200002190 6200007000 6200005700 6200005720 6200008440 6200008440 6200006670
S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL
NSVA468 (433.92MHZ) FL-298 (21.700 MHz) CFWM450E
ELJFC 2R2K-F LL1608-F18NK ELJRE 12NG-F 0.26-1.0-5TL 17N 0.26-1.0-5TL 17N ELJRE 22NG-F MLF1608K 100K-T MLF1608K 100K-T LQN 1A 27NJ04 ELJRE 33NG-F ELJRE 82NG-F ELJRE 27NG-F ELJRE 22NG-F 0.20-1.0-4TL 15N MLF2012A 4R7K-T ELJRE 82NG-F ELJRE 22NG-F ELJRE 33NG-F LQN21A 8N2D04 LQN21A 8N2D04 ELJRE 68NG-F
S.=Surface mount 6-2
[RF UNIT] REF NO.
[RF UNIT]
ORDER NO.
DESCRIPTION
L206 L207 L208
6200005690 S.COIL 6200005690 S.COIL 6200003640 S.COIL
ELJRE 18NG-F ELJRE 18NG-F MLF1608K 100K-T
R1 R2 R3 R4 R5 R6 R7 R10 R12 R16 R19 R25 R27 R29 R30 R31 R32 R33 R34 R35 R36 R37 R45 R50 R51 R52 R53 R54 R55 R56 R57 R58 R59 R60 R61 R62 R64 R65 R66 R67 R68 R69 R70 R71 R72 R73 R74 R75 R76 R83 R86 R88 R93 R202 R205
7030003430 7030003670 7030003470 7030003450 7030003680 7030003520 7030003280 7030003550 7030003440 7030003260 7030003400 7030003620 7030003640 7030003350 7030003620 7030003620 7030003540 7030003550 7030003420 7030003640 7030003360 7030003600 7030003520 7310003630 7030003770 7030003410 7030003680 7510000930 7030003580 7030003580 7030003450 7030003520 7030003470 7030003680 7030003560 7030003230 7030003650 7030003500 7030003570 7030003780 7030003750 7030003510 7030003610 7030003560 7030003550 7030003780 7030003750 7030003560 7030003510 7030003560 7030003300 7030003560 7030003200 7030003540 7030003440
ERJ3GEYJ 821 V (820 Ω) ERJ3GEYJ 823 V (82 kΩ) ERJ3GEYJ 182 V (1.8 kΩ) ERJ3GEYJ 122 V (1.2 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 472 V (4.7 kΩ) ERJ3GEYJ 470 V (47 Ω) ERJ3GEYJ 822 V (8.2 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 330 V (33 Ω) ERJ3GEYJ 471 V (470 Ω) ERJ3GEYJ 333 V (33 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 181 V (180 Ω) ERJ3GEYJ 333 V (33 kΩ) ERJ3GEYJ 333 V (33 kΩ) ERJ3GEYJ 682 V (6.8 kΩ) ERJ3GEYJ 822 V (8.2 kΩ) ERJ3GEYJ 681 V (680 Ω) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 221 V (220 Ω) ERJ3GEYJ 223 V (22 kΩ) ERJ3GEYJ 472 V (4.7 kΩ) EVM-1XSX50 BQ4 (473) ERJ3GEYJ 564 V (560 kΩ) ERJ3GEYJ 561 V (560 Ω) ERJ3GEYJ 104 V (100 kΩ) NTCCF2012 3NH 103KC-T ERJ3GEYJ 153 V (15 kΩ) ERJ3GEYJ 153 V (15 kΩ) ERJ3GEYJ 122 V (1.2 kΩ) ERJ3GEYJ 472 V (4.7 kΩ) ERJ3GEYJ 182 V (1.8 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 180 V (18 Ω) ERJ3GEYJ 563 V (56 kΩ) ERJ3GEYJ 332 V (3.3 kΩ) ERJ3GEYJ 123 V (12 kΩ) ERJ3GEYJ 684 V (680 kΩ) ERJ3GEYJ 394 V (390 kΩ) ERJ3GEYJ 392 V (3.9 kΩ) ERJ3GEYJ 273 V (27 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 822 V (8.2 kΩ) ERJ3GEYJ 684 V (680 kΩ) ERJ3GEYJ 394 V (390 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 392 V (3.9 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 680 V (68 Ω) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 100 V (10 Ω) ERJ3GEYJ 682 V (6.8 kΩ) ERJ3GEYJ 102 V (1 kΩ) [ITA], [ITA-1] NTCCM1608 3NH 221KC [CSA], [CSA-1] EVM-1XSX50 B14 (103) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 221 V (220 Ω) ERJ3GEYJ 181 V (180 Ω) ERJ3GEYJ 270 V (27 Ω) ERJ3GEYJ 181 V (180 Ω) ERJ3GEYJ 221 V (220 Ω) ERJ3GEYJ 102 V (1 kΩ) [CSA], [CSA-1] ERJ3GEYJ 123 V (12 kΩ) [ITA], [ITA-1]
S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.TRIMMER S.RESISTOR S.RESISTOR S.RESISTOR S.THERMISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR
7510001180 S.THERMISTOR R206 R207 R208 R209 R210 R211 R212 R213 R301
7310003610 7030003440 7030003440 7030003360 7030003350 7030003250 7030003350 7030003360 7030003440
S.TRIMMER S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR
7030003570 S.RESISTOR
C1 C2 C3 C4 C5
4030006860 4030008920 4030008920 4030006850 4030006850
S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC
C1608 C1608 C1608 C1608 C1608
JB JB JB JB JB
1H 1C 1C 1H 1H
102K-T-A 473K-T-A 473K-T-A 471K-T-A 471K-T-A
REF NO.
ORDER NO.
C6 C7 C8 C9 C10 C11 C12 C13 C15 C16 C17 C18 C20 C21 C23 C26 C28 C30 C31 C32 C35 C36 C42 C43 C44 C45 C46 C48 C50 C51 C52 C53 C54 C55 C56 C57 C60 C61 C62 C63 C64 C65 C67 C68 C69 C70 C72 C73 C74 C75 C76 C77 C78 C79 C80 C81 C82 C83 C84 C85 C86 C87 C88 C89 C90 C91 C92 C93 C95 C96 C100 C102 C201 C202 C203 C204 C205 C206 C207 C208 C209 C210
4030006850 4030007050 4030006970 4030010780 4030007010 4030009470 4030006990 4030006860 4030008920 4030006850 4030008880 4030006860 4030006850 4030006850 4030006940 4030006850 4030006850 4030006980 4030006980 4030006970 4030006910 4030007010 4030007070 4030007030 4030007060 4030007010 4030007050 4030006900 4030007020 4030007020 4030006930 4030009540 4030009350 4030006850 4030006910 4030009540 4510005430 4030006960 4030006900 4610002150 4030009660 4030006850 4030011600 4550006150 4030006990 4030006850 4030006850 4030011600 4030006850 4030006850 4030006850 4030007050 4030007110 4510004630 4030009660 4030008920 4030011600 4030008680 4030006850 4510004650 4030011810 4030011600 4510004650 4030009880 4030006900 4030008920 4030006900 4030006900 4030006850 4030006850 4030007050 4030009540 4030006850 4030007050 4030007050 4030006990 4030006860 4030006860 4030006990 4030007000 4030006970 4030006980
DESCRIPTION S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.TRIMMER S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC
C1608 JB 1H 471K-T-A C1608 CH 1H 220J-T-A C1608 CH 1H 060D-T-A C1608 CH 1H 1R5C-T-A C1608 CH 1H 100D-T-A C1608 CH 1H R75C-T-A C1608 CH 1H 080D-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 473K-T-A C1608 JB 1H 471K-T-A C1608 JB 1C 223K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 471K-T-A C1608 JB 1H 471K-T-A C1608 CH 1H 030C-T-A C1608 JB 1H 471K-T-A C1608 JB 1H 471K-T-A C1608 CH 1H 070D-T-A C1608 CH 1H 070D-T-A C1608 CH 1H 060D-T-A C1608 CH 1H 0R5C-T-A C1608 CH 1H 100D-T-A C1608 CH 1H 330J-T-A C1608 CH 1H 150J-T-A C1608 CH 1H 270J-T-A C1608 CH 1H 100D-T-A C1608 CH 1H 220J-T-A C1608 JB 1E 103K-T-A C1608 CH 1H 120J-T-A C1608 CH 1H 120J-T-A C1608 CH 1H 020C-T-A C1608 CH 1H 1R5B-T-A C1608 CH 1H 3R5B-T-A C1608 JB 1H 471K-T-A C1608 CH 1H 0R5C-T-A C1608 CH 1H 1R5B-T-A ECEV0JA220SR C1608 CH 1H 050C-T-A C1608 JB 1E 103K-T-A CTZ3S-10A-W1-AF C1608 JF 1C 224Z-T-A C1608 JB 1H 471K-T-A C1608 JB 1C 104KT-N ECST1CY105R C1608 CH 1H 080D-T-A C1608 JB 1H 471K-T-A C1608 JB 1H 471K-T-A C1608 JB 1C 104KT-N C1608 JB 1H 471K-T-A C1608 JB 1H 471K-T-A C1608 JB 1H 471K-T-A C1608 CH 1H 220J-T-A C1608 CH 1H 680J-T-A ECEV1CA100SR C1608 JF 1C 224Z-T-A C1608 JB 1C 473K-T-A C1608 JB 1C 104KT-N C2012 JF 1C 105Z-T-A C1608 JB 1H 471K-T-A ECEV1EA4R7SR C1608 JB 1A 224K-T-N C1608 JB 1C 104KT-N ECEV1EA4R7SR C1608 JB 1H 682K-T-A C1608 JB 1E 103K-T-A C1608 JB 1C 473K-T-A C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1H 471K-T-A C1608 JB 1H 471K-T-A C1608 CH 1H 220J-T-A C1608 CH 1H 1R5B-T-A C1608 JB 1H 471K-T-A C1608 CH 1H 220J-T-A C1608 CH 1H 220J-T-A C1608 CH 1H 080D-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 080D-T-A C1608 CH 1H 090D-T-A C1608 CH 1H 060D-T-A C1608 CH 1H 070D-T-A
S.=Surface mount 6-3
[RF UNIT] REF NO.
ORDER NO.
DESCRIPTION
C211
4030006860 S.CERAMIC
C1608 JB 1H 102K-T-A
J1 J2
6910007660 CONNECTOR 6510018170 S.CONNECTOR
IMSA-9210B-1-02T 4-175643-4
W4 W5 W6 W8 W201 W202
7030003860 7030003860 7030003860 7030003860 7030003860 7030003860
ERJ3GE ERJ3GE ERJ3GE ERJ3GE ERJ3GE ERJ3GE
EP1
0910050351 PCB 0910050781 PCB
S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER
B 5162A B 5162A
JPW JPW JPW JPW JPW JPW
V V V V V V
[ITA], [ITA-1] [CSA], [CSA-1]
S.=Surface mount 6-4
SECTION 7
MECHANICAL PARTS AND DISASSEMBLY 7-2 ACCESSORIES
7-1 CABINET PARTS [CHASSIS PARTS] REF. NO. ORDER NO.
REF. NO. ORDER NO. DESCRIPTION
SP1
2510000960 Speaker K036NA500-26A27
1
EP1
3310002090 Antenna 2045ANT
1
MP1
8210015181 Panel 2045 Front Panel-1 [ITA], [CSA] 8210016101 Panel 2045 Front Panel (A)-1 [ITA-1], [CSA-1] 8210015191 Panel 2045 Rear Panel-1 [ITA], [CSA] 8210016111 Panel 2045 Rear Panel (A)-1 [ITA-1], [CSA-1] 8110006400 Cover 2045 Rear Cover [ITA], [CSA] 8110006720 Cover 2045 Rear Cover (A) [ITA-1], [CSA-1] 8110006410 Cover 2045 Lock Cover [ITA], [CSA] 8110006730 Cover 2045 Lock Cover (A) [ITA-1], [CSA-1] 8310042680 Plate 2045 Window Plate 8210015220 Panel 2045 Reflector 8610010570 Knob N-265 8930045192 Seal 2045 Top Seal-2 8930045230 Key 2045 4-Key 8930045200 Button 2045 PTT Button 8930046990 Seal 2045 Main Seal (A) 8930045220 Seal 2045 BATT Seal 8930046280 Terminal 2045 ANT Termainal 8830001370 Screw 2045 VR Nut 8930045750 Seal O-ring (X) 8830000110 Screw Nut M4 8810009560 Screw PH BO 2x6 ZK (BT) 8810008640 Screw FH BO 2x4 NI-ZU (BT) 8810008990 Screw PH BO 2x10 ZK (BT)
1 1
MP2
MP3 MP4 MP5 MP7 MP8 MP9 MP10 MP11 MP12 MP13 MP14 MP20 MP22 MP23 MP24 MP25 MP30
MP1 MP2
QTY.
MP1
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 4 2 1
[MAIN UNIT] REF. NO. ORDER NO.
DESCRIPTION
QTY.
DS2
5030001580 LCD LD-BU10185J
1
EP1
8930045510 LCD contact SRCN-2045-SP-N-W
1
[RF UNIT] REF. NO. ORDER NO. MP1
DESCRIPTION
8510011570 Case 2045 VCO Case
Screw abbreviations
DESCRIPTION
8930045331 2045 Belt clip-1 8820001040 2045 Screw
QTY. 1
A, B0, BT: Self-tapping PH: Pan head FH: Flat head BiH: Bind head NI: Nickel SUS: Stainless ZK: Black
7-1
QTY. 1 1
MP2
EP1 (C)
MP11 (C) MP22 (C)
MP24 (C) MP8 (C)
MP23 (C)
MP9 (C)
MP30 (C)
MP14 (C)
MP25 (C)
MP1 (RF)
MP20 (C)
MP3 (C)
MP7 (C) MP13 (C)
MP25 (C)
DS2 (M)
RF unit
MP10 (C)
MP24 (C)
EP1 (M) MP1 (C)
MP2 (C) MP4 (C)
MAIN unit
SP1 (C)
MP5 (C)
MP12 (C)
UNIT abbreviation (C): CHASSIS PARTS, (RF): RF UNIT, (M): MAIN UNIT
7-2
SECTION 8
SEMI-CONDUCTOR INFORMATION
• TRANSISTOR AND FET’S 2SA1362 GR (Symbol: AEG)
2SA1586 GR (Symbol: SG)
B
2SB798 DK (Symbol: DK)
2SC4081 S (Symbol: BS)
B
B
B
C
C
E
2SC3356 R24 (Symbol: R24)
B
C
C
C E
E
C E
E
2SC4213 B (Symbol: AB)
2SC4215 O (Symbol: QO)
2SC4226 R25 (Symbol: R25)
2SC4228 R44 (Symbol: R44) B
B
B C
C
E
E
2SC5194 (Symbol: T88)
2SJ144 Y (Symbol: VX)
2SK1829 (Symbol: K1) E
C
B
C
MRF9745 (Symbol: M745) E
B
E
C
E
B
E
C E
E
UMZ2N (Symbol: Z2)
UMZ1N (Symbol: Z1)
C
B C
D
DTC114 EU (Symbol: 14)
DTA144 EU (Symbol: 16)
B
G
E
C E
DTA114 EU (Symbol: 16)
S
B
2SC5108 Y (Symbol: MC)
UN5119 (Symbol: 6K)
E1
C1
E1
C1
B1
B2
B1
E2
C2
E2
B2
C2
B C E
UN9215 (Symbol: 8E) B C E
• DIODES 1SS355 (Symbol: A)
1SV284 (Symbol: TL )
MA77 (Symbol: 4B)
A
MA2S077 (Symbol: S)
K
MA2S728 (Symbol: B)
8-1
MA2S111 (Symbol: A)
SECTION 9
BOARD LAYOUTS
9-1 MAIN UNIT TOP VIEW (IC-4008A)
D2
C20
C95
R22
R61
C15
DS1
C9
D5
C63
IC5
C50 R56
R55
C74
R90
C71
Q27 D101
C60
C75
R115
R200
R119
Q101
R76
C53
Q14
R114
R74
Q11
R89 R201
R24
W3
R49
C42 R26
R98
R25
C97
C96
R27
Q28
DS2 C49
C48 C18
C81
C55
R23
C17
C52
C35
R42
C90
R43
R41
R37
R12
C62
C67
R80
C32 R38
C8 R36 C31
W7 C89
R77
R46
D4
Q7
MC1 C7 R202
R13
C64
Q3
C79 C4
9-1
C3 R9
C25
Q6 R110
R31
C5
R118
R50
C57
C34
Q25
R45
C65
C80
R10
R78
C36
Q18
C88
IC6
•
• BOTTOM VIEW (IC-4008A) to RF unit J2
1
13
PSC BATT MOD T+3 VOL R+3 GND
UNLK CK DATA STB SQL SENS AF
J4
2
R86
R88
R58
14
C21
J3 Q23
C72
R54
C47
C59 R87
R106
J1
C82
IC9
R69
J4
Q5
R68
IC3
C44
Q10
S1 R112
C86
R81
IC1
C46
R97
C10
R95
R62
C92
R70
C40
C91
R67
R57
R96
C51
C94
R14
9-2
C87
C54
C56
C61 R103
R71
C26
Q12
R35
Q29
C27
R34
R32
R105
C28
Q2 R102
R33
R53
C11
R7
C24
R5
C93
R94
R4
R40
R79
R101
R52
X1
C45
R100
R51
R72
R63
R99
Q1
R2
IC2
R108
R6
C85
R60
W4
C1
C83
C98
R66
R64
W1
C6
R39 R30
R65
C29
C73
R22
D2
C20
C95
C15
R61
DS1
C75
R56
C71
Q27
R24 C50
R55
R26
R90
R25 W3
C9
R89
R114
Q14
R98
C42
C74
R74
Q11
R49
C97
C96
R27
C53
Q28
D303
R76
D101 R302 D5
C63
C60
DS2
IC5
C49
C48 C18
C81
C55
C52
R23
C17
C35
R42
C90
R43
R41
R37
R12
C62
C67
R80
C32 R38
C8
C7
R13
R202
C64
Q3
C79
9-3
C3 R9
C25
Q6 R110
IC6
R31
C5
R118
C4
R50
C57
C34
R36 C31
W7 C89
R77
R46
D4
Q7
MC1
Q25
R45
C65
C80
R10
R78
C36
Q18
C88
C10
Q12
C91
9-4 C61
R103
R35
R62
R100 C45
R101
C51 R97
R14
X1
R99 R63 R72
R81
R112
C87 C54
IC1
C56
C86
R94
J4 R69
R68
IC3
C82
R96
R106
C92
R52
C94
Q10 R301
R87
R57
R51
C21
R86
R88
2
R67
C28 R65
R64 R66
C47
Q23
R70
Q2 R60
Q44
R54
C59
C26
W1
Q5
PSC BATT MOD T+3 VOL R+3 GND
UNLK CK DATA STB SQL SENS AF
J4 to RF unit J2
R71
R102 R32
C85 W4
C1
R34
Q1
R39
C40
R2 R108
C29
R58
R95
R105
R4
C6
R30
R33
R53
Q29
C24
C27
C93 R40
IC2
R5
C83
C11
C98 R7
R6
1 13
14
J3
C72
IC9
J1
S1
C73
C46
R79
9-2 RF UNIT TOP VIEW
GND R+3 VOL T+3 MOD BATT PSC
J2
to MAIN unit J4 1
AF SENS SQL STB DATA CK UNLK
13
14
C81
2
R60
C82
C48
R27
R58
C43
C13
C67
IC1 C86
J2 Q2
R64
9-5
L208
C68
W4 C18 C201
L201
W201
C203 C204 L202
L204
C26
C202
L10
C8
C10
C12
L5
R10
C87
R202
Q202
C44
D7 C207
C9
C62 R62
L205
C31
C208
C30
L23
C11
L203
C96
C72
C206
R93
Q201
R213
R209
L6
W5 L15
W6 C23 W202
R205
C90
C65
D8
C70
L1 D103
R68
R67
C61
Q13
Q14
R86
R19
C89
R66
Q15
C46
R65
R12
L25
C28
R4
C3
C36
R69
C4
R32
D9
R5
R71
•
R45 C17
C1
C73 R51
C78
C79
C77
IC2
C80 C74
• BOTTOM VIEW
C2
C83 D1
R212
L19
FI2
C45
L21
Q8
R37
C102 C21
R210
R50
C84
Q12
Q7
C64 R33
R206
C5
R76
R16
R75
R207
D5
R31
C205
R83
C32 R30
R70 R72
R25
9-6
L4 C209
C7
C210
L11
R73 C95
R74
L206
C93
Q16
L3
R7
C6
Q3
C85
D101
C51
C20
D102
C53
L13
Q6
R29
C91
C88
C50 C52
C92
D4
R34
R301
L12 R54
C56
FI3
C60
R36
FI1
L14
R35
Q1
C35
C55 C57
R2
W8 R3
C16
X2
L105 R211
C69
R1
R6
C211
C15
C63
D2
R208 L207
R57
R55
R54
R59
C100
C76
R56
R61
R53
X1
C75
C42
R88
R52
J1
SECTION 10
BLOCK DIAGRAM
CHASSIS UNT ANT
RF UNIT TX/RX: 433.075-434.775MHz X2 CDBCA450CX24 (450 kHz)
IC2 TA31136FN FI3: CFWM450E IF AMP
Q2 2SC4226
FI2
Q1
2nd MIX
CERAMIC BPF (450 kHz)
IF AMP
Q13: 2SC4081 Q14: 2SA1586 D8 : 1SS355 D9 : 1SS355
FL-298
2SC4215 2nd.Lo: 21.25 MHz FMDET
LOOP FIL
PLL IC
UNLOCK
VCO REG
BUFF
LO SW
ATT
Q12 2SC5108
LPF
PRE DRIVE
D103
Q201
TX/RX SW
DRIVE AMP
TX: 433.075-434.775MHz PWR AMP Q202: MRF9745
Q7 2SC5108
AF FIL
HPF
1st.LO: 411.375-413.075MHz
VCO
X1 CR-632 (21.25 MHz)
ANT SW D7: MA2S077 D101: MA2S077 D102: MA2S077
Q8 2SC4228
DATA,CK,STB NOISE DET
RF AMP
BPF 1st MIX
Q6: 2SC5108 D4,D5: 1SV284
IC1 TB31202FN
S DET
Q3: 2SC5194
FI1: NSVA468
1st.IF: 21.7 MHz
XTAL BPF
D1: MA77 D2: MA77
MA2S728
2SC3356
R50 MOD LEVEL SET
SHIFT
POWER SET R206
Q15: 2SC4081 Q16: 2SC4081
MAIN UNIT
MODSW Q1 DTA144EU
AF
LPF
VOL
Q6 2SK1829
IC2B NJM2100M
IC2A NJM2100M
Q29: DTC114EU MIC SW
MIC MUTE
IDC
+3V
MIC
MIC1 KUC3523
TXMOD J1 MIC JACK
PSC
SQL
SENS
MMUT Q7 2SC4081
EEP ROM
TONE LPF
D/A
IC3 X24C01AS
CTCIN
Q12 2SC4081
PTT SENSE
Q2: UN9215 Q3: UN5119
TONE LPF
Q23 2SJ144 VOL MUTE R58 AF VOL
MICSW
X1 CR-627
PTT2
CPU
5.8368 MHz
RMUT
IC1 µPD753036GK
D2 1SS355
REMIN
IC9 NJM2070M
PROTECTOR
J3 SP JACK
AF AMP
AFON TXV
POWER
RXV POWER
MODE Q14 DTA114EU UP
IC5
DS2 LCD
DOWN
VOLT SENS
LED DRV RESET S-80928ANMP
S1 PTT
IC6 S-81230SG +3V CURRENT AMP
DS1 LN1371G
R+3 CURRENT AMP
Q18 2SA1586
T+3 CURRENT AMP
TO LOGIC
Q5 : 2SA1362 Q10: 2SC4081 Q11: 2SC4213
BATT
+3 REG
[ITA/-1] Q27 : 2SC4081 Q28 : 2SB798 D5: MA2S111 D101: MA2S111 D303: MA2S111
Q25: UMZ2N D4: 1SS355
+3V
[CSA/-1] Q27 : 2SC4081 Q28 : 2SB798 Q101: UMZ1N D5: 1SS355 D101: 1SS355
R+3
SP1 AF MUTE
BATTERY
CHASSIS UNIT
T+3
COMON LINE TX LINE RX LINE DATA BUS LINE
10 - 1
SECTION 11
VOLTAGE DIAGRAM
11-1 MAIN UNIT
C : COMMON T : TX R : RX SO : SQL OPEN SC : SQL CLOSE LON : LIGHT ON LOF : LIGHT OFF
R60 100 k
R98 100 k
R99 100 k
R100 100 k
R101 100 k
R102 100 k
J4 4-175638-4 to RF unit J2 UNLK CK DATA STB SQL SENS AF
1 3 5 7 9 11 13
PSC BATT
2 4 6 8 10 12 14
T+3 VOL R+3
C44 0.1
W1
W4
C90 470 P
S1 SW-149 [PTT]
[DOWN]
[UP]
R12 10
MOD
[MOD] [POWER]
C: 3.12 T: 0 R: 3.02
Q1 DTA144EU
R89 1k C74 0.001
C: 3.12 C: 3.10
J1 HSJ-1102-01-540
C: 0 R13 4.7 k
PTT2 C75 0.001
IC2a NJM2100M
R71 33 k R96 100 k
T: 1.48 R: 0
R2 82 k
2
1
R4 82 k
C1 0.0015
R5 1.2 M
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 DS1 LN1371G
40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21
R36 10 k
R37 22 k
C: 1.95
C40 0.1
R38 22 k
R105 10 k
C31 0.022
R35 5.6 k PTT2
C34 0.0047
C32 0.1
C82 0.047
R65 18 k
R110 1M
C26 470 P
R32 680 k
R41 4.7 k
R34 6.8 k
R33 6.8 k
R42 3.9 k
TO RF unit
T: 2.77 SO: 0 SC: 2.77
Q23 2SJ144
C21 0.1
C59 470 P
R87 1M
C28 0.047
R22 33 k R58 RV-244 10 k
R88 100 k
R86 100 k
C72 0.01
C27 0.1
C15 0.1
R27 100
RMUTE T: 0 SC: 0 SO: 4.50
AFON R74 10 k
S25 S24 S23 S22 S21 S20 S19 S18 S17 S16 S15 S14 S13 S12
BATIN C61 0.1
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17
REMIN
R24 1.5 M
R79 220 k
R80 100 k
DS2 LD-BU10185J
T: 3.04 R: 2.40
Q5 2SA1362
T: 3.94 SO: 3.79 SC: 3.98
C56 0.1
R94 220 k
SEG25 SEG24 SEG23 SEG22 SEG21 SEG20 SEG19 SEG18 SEG17 SEG16 SEG15 SEG14 SEG13 SEG12 COM0 COM1 COM2
R61 47
T: 3.00 R: 0
R43 56 k
BEEP LON: 2.82 LOF: 0
C25 470 P
R31 1M
W6
Q12 2SC4081
R66 18 k
C11 470 P
Q29 DTC114EU
C35 0.1
T: 0 R: 0.86
C51 0.1
C10 470 P
T: 2.75 R: 0
C: 1.65
R57 15 k
R14 3.3 k
R118 4.7 k
BEEP
R64 18 k
T: 0 R: 3.12
C5 470 P
MMUTE
Q7 2SC4081
R106 10 k
REMIN
LON: 0 LOF: 3.02
Q14 DTA114EU
RESET EEPCK EEPDA PSC RXV TXV LAMPC MICSW MMUTE
P02/SO/SB0 P01/SCK P00/INT4 P53 P52 P51 P50 VSS P43 P42 P41 P40 VLC2 VLC1 VLC0 BIAS COM3 COM2 COM1 COM0
MC1 KUC3523
C79 0.1 R50 4.7 k
R9 100 k C93 330 P
R53 1.5 M
C: 3.10
C4 0.1
C3 0.1
R52 330 k
C95 330 P
C91 470 P
C24 0.033
T: 1.60 R: 0
R45 2.2 M
C36 0.001
R46 100
COM2
C46 24 P
AN3 AN4 AN5 AVSS AVREF VDD XT1 XT2 IC X1 X2 RESET P60/KR0 P61/KR1 P62/KR2 P63/KR3 P70/KR4 P71/KR5 P72/KR6 P73/KR7
R62 100 k
COM0 COM1
R72 1M
X1 CR-627
AN2 AN1 AN0 P83/AN7 P82/AN6 P81/TI2 P80/TI1 P33 P32 P31/SYNC P30/LCDCL P23/BUZ P22/PCL/PTO2 P21/PTO1 P20/PTO0 P13/TI0 P12/TNT2 P11/TNT1 P10/TNT0 P03/SI/SB1
60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41
R63 5.6 k
61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80
S31/BP7 S30/BP6 S29/BP5 S28/BP4 S27/BP3 S26/BP2 S25/BP1 S24/BP0 S23 S22 S21 S20 S19 S18 S17 S16 S15 S14 S13 S12
C54 0.1
C45 24 P
R51 470 k
W3
R10 82
Q6 2SK1829
R7 1.2 k
C83 0.1
C85 0.1
T-ID R68 R69 18 k 18 k
7
R108 33 k
R40 47 k
RXD
4
C7 0.1
5 6
C73 0.0033
Q3 UN5119
C6 1
R6 180 k
T: 1.58 R: 0
IC2b NJM2100M
T: 1.46 R: 0
R39 82 k
3
8
Q2 UN9215
T: 3.05 R: 0
C29 270 P
R30 68 k
R103 100 k
TEST BEEP UNLK TEST CLIN
REMIN SQLIN CTCIN TXMOD CTCO2 CTCO1 CTCO0 POWER PLLST PLLDA PLLCK AFON RMUTE
8 VCC 7 NC 6 SCL 5 SDA BATIN
NC NC NC VSS
C87 470 P
SENIN
1 2 3 4
R70 68 k R97 100 k
C92 470 P
C53 0.1
IC3 X24C01AS
T: 1.45 R: 0
R67 18 k
C42 0.01
C9 470 P
R95 4.7 k
R90 1k
R49 100
C8 10
R202 100
T: 0 SO: 2.95 SC: 0
Q18 2SA1586 T: 0 R: 2.97
C67 2.2
R23 15 k
Q10 2SC4081
C55 3.3
R81 10 k
C49 0.1
C48 22
T,SC: 0.49 SO: 0.61
4
5
R55 120
R54 1.2 k
C47 470 P
8 7 6
C52 2.2
TXV RXV
C97 330 P
R56 1
Q11 2SC4213
R+3
SP1 CHASSIS
C96 330 P
R26 10 k
C50 0.1
T: 0 SO: 2.33 SC: 0
J3 HSJ1493-01-010
C18 10
C17 150
IC9 NJM2070M
D2 1SS355
C20 0.1
T,SC: 0.43 SO: 1.93
R25 12 k 1 2 3
W5
R+3 BATT
R76 100 k
C: 3.82
IC5 S-80928ANMP 1 OUT 2 VDD 3 VSS
+3 V C60 0.1
NC NC
5
C: 3.02
3
4
2
Q25 UMZ2N 4
5
6
+3 V C: 2.50 W7 C: 3.13
C80 100/4 V
C88 470 P
C62 0.1
R77 470
C57 0.1
C65 0.1
1
C94 330 P
C81 0.033
[ITA/-1]
C63 0.1
R302 D101 1k MA2S111
1 GND 2 VIN 3 VOUT
NC NC
5 4
R112 33 k [ITA/-1] 10 k [CSA/-1]
D101 1SS355 C: 3.02 C89 470 P
[CSA/-1]
Q28 2SB798
R301 [ITA/-1] 118 k
3
2
1
4
5
6
[CSA/-1] T: 2.68 R: 0 R114 1.2 k [ITA/-1] 3.3 k [CSA/-1]
C71 0.1
[CSA/-1]
T: 0.43 R: 0
R201 270
R115 560
11 - 1
R119 100 k
Q28 2SB798
T: 3.70 R: 4.00
[ITA/-1] D5 D303 MA2S111 [ITA/-1] MA2S111 1SS355 [CSA/-1]
[CSA/-1]
[ITA/-1] T: 0.50 R: 0
T: 1.07 R: 0
Q101 UMZ1N
Q27 2SC4081
C86 2.2
C64 22
D4 1SS355
[ITA/-1]
R200 2.2 M
IC6 S-81230SG
R78 10 k
[CSA/-1]
[ITA/-1] [CSA/-1] T: 1.56 T: 3.70 R: 0 R: 0
C98 330 P
11-2 RF UNIT C: COMMON T: TX R: RX
EP1
T: 0 R: 2.61 1 C45 10 P
2 3
4
5
6
7
8
C7 22 P
R16 33
C75 470 P R53 100 k
C73 0.1
5
8 7 6 5 4 3 2 1
T: 0 R: 0.72
FILIN FILOUT BIAS IFIN VDD MIXOUT OSCOUT OSCIN
T: 0 R: 1.86 C1 0.001
R1 820
AFOUT QUADIN IFOUT SOUT NDET NOUT VSS MIXIN
R56 15 k C76 470 P
R2 82 k
R3 1.8 k
FI2 FL-298
W8
C36 10 P
C46 22 P
R5 100 k
R4 2.2 k
1 2
C10 10 P
J1 IMSA-9210B-1-02T
RF TEST PORT
C12 8P
1st LO
T: 0 R: 0.72
Q2 2SC4226
C28 470 P
R19 470
T: 0.42 R: 0.36
C16 470 P
R27 47 k
R6 4.7 k C: 2.83
C4 470 P
C79 10
T: 0 R: 1.12
C15 0.047
C: 2.80 L19 27 nH
C35 0.5 P
Q1 2SC4215
R205 NTCCM16083NH221KC [CSA/-1]
T+3
1 FIN1 2 VCC 3 CP1 4 GND 5 LD 6 CK 7 DATA 8 STB
FIN2 16 15 VCC 14 CP2 13 GND 12 SW 11 XIN 10 XOUT 9 BO
C61 5P W4
C100 22 P
C62 0.01
C48 0.01
R10 8.2 k
C17 0.022
C18 0.001 R211 27 C69 8P
R210 180
R45 4.7 k
X1 CR-633
D2 MA77 R212 180
R37 22 k
L105 82 nH
C211 0.001
C26 470 P
C201 470 P
C21 470 P
R12 1k
L207 18 nH
W6
T: 1.38 R: 0
R86 68
C70 470 P
C88 4.7 D1 MA77
IC1 TB31202FN
C3 0.047
T: 0 R: 2.96
C8 6P
T: 1.47 R: 0
C13 0.001
L1 2.2 µH
R58 4.7 k C77 22 P
C11 0.75 P
C65 470 P
T: 0 R: 1.98
C2 0.047
9 10 11 12 13 14 15 16
R59 1.8 k
D101 MA2S077
D102 MA2S077
C6 470 P
C5 470 P
2nd LO
R55 15 k
C9 1.5 P
D7 MA2S077
L23 15 nH
R+3
(21.25 MHz)
IC2 TA31136FN
L6 17 nH
T: 0 R: 1.76
4 3
R51 560 k
R54 NTCCF20123NH
L5 17 nH
T: 1.16 R: 0
R208 1k
L21 22 nH
C23 3P
C102 1.5 P
L201 22 nH
W202
T: 0.75 R: 0.84
C203 22 P
Q201 2SC3356
C208 9P
L204 8.2 nH
C204 8P
R207 1k
C207 8P
Q202 MRF9745 C205 0.001
R301 12 k [ITA/-1] 1 k [CSA/-1]
D103 MA2S728
C68 1
T: 1.20 R: 0
C202 22 P
L202 33 nH
R213 220
L203 8.2 nH
C206 0.001
T: 1.51 R: 0
R202 6.8 k
Q8 2SC4228
T: 0.72 R: 0
R205 1 k [ITA/-1]
R206 EVM-1X B14 10 k
R52 560
C209 6P
C30 7P
L10 22 nH
R25 33 k
R7 47
FI3 CFWM450E 2 1
C210 7P
C44 27 P
W201
T: 0 R: 2.60
Q3 2SC5149
C31 7P
L206 18 nH
L4 12 nH
L3 18 nH
C74 470 P
T: 0.57 R: 0
T: 0 R: 0.82
C32 6P
FI1 NSVA468
R33 8.2 k R57 1.2 k
C42 33 P
R88 10 k
C78 68 P
C43 12P
C63 CTZ3S-20C 20 P
C80 0.22 R60 100 k
X2 CDBCA450CX24
C81 0.047
C64 0.22
R32 6.8 k
C82 0.1
C83 1
R50 EVM-1XBQ4 47 k
R61 10 k
C85 4.7
R30 33 k
C20 470 P
R29 180
R76 3.9 k
R67 680 k
C89 0.0068
C96 470 P
R71 10 k
C91 0.047 R66 12 k
C90 0.01
R68 390 k
UNLK T: 0 R: 0.95
C92 0.01
Q15 2SC4081
R72 8.2 k
CK DATA
Q16 2SC4081
STB SQL SENS
R69 3.9 k
11 - 2
T: 0 R: 1.82
R70 27 k
C93 0.01
R74 390 k R73 680 k
AF
1
2
3
4
5
6
7
8
9
10
11
12
13
14
VOL R75 10 k
T: 0 R: 1.72
R83 10 k
J2 4-175643-4
D5 1SV284
L11 10 µH
MOD
T: 0 R: 0.99
L12 10 µH D4 1SV284
T: 0.18 R: 0.78 C67 0.1
T: 2.85 R: 0.01
Q12 2SC5108
PSC
R34 680
C54 3.5 P
R36 220
C: 1.22
C52 2P
C50 12 P L13 27 nH C51 12 P
R31 33 K
L14 33 nH
C56 0.5 P R35 47 k
C53 1.5 P
C: 2.01 C60 22
C55 470 P
L15 82 nH
C57 1.5 P
C: 0.75 C: 0.70
Q6 2SC5108
Q7 2SC5108
W5
L208 10 µH
D9 1SS355
C: 2.99
C84 470 P
Q13 2SC4081
C: 3.06
R62 18
Q14 2SA1586 C: 4.5
C: 2.49 L205 68 nH
R64 56 k C: 3.02
C86 0.22
R65 3.3 k
D8 1SS355
R93 10
C87 0.1
BATT C72 470 P
T+3 R+3 L25 4.7 µH
T: 1.56 R: 0.02 C95 470 P
T: 0 R: 2.96
R209 220
6-9-16, Kamihigashi, Hirano-ku, Osaka 547-0002, Japan Phone : 06 6793 5302 Fax : 06 6793 0013
< Corporate Headquarters > 2380 116th Avenue N.E., Bellevue, WA 98004, U.S.A. Phone : (425) 454-8155 Fax : (425) 454-1509 URL : http://www.icomamerica.com < Customer Service > Phone : (425) 454-7619
A Division of Icom America Inc. 3071 #5 Road, Unit 9, Richmond, B.C., V6X 2T4, Canada Phone : (604) 273-7400 Fax : (604) 273-1900
A.C.N. 006 092 575 290-294 Albert Street, Brunswick, Victoria, 3056, Australia Phone : 03 9387 0666 Fax : 03 9387 0022 URL : http://www.icom.net.au
6F No. 68, Sec. 1 Cheng-Teh Road, Taipei, Taiwan R.O.C. Phone : (02) 2559 1899 Fax : (02) 2559 1874
Communication Equipment Himmelgeister Str. 100, D-40225 Düsseldorf, Germany Phone : 0211 346047 Fax : 0211 333639 URL : http://www.icomeurope.com
Crta. de Gracia a Manresa Km. 14,750 08190 Sant Cugat del Valles Barcelona, SPAIN Phone : (93) 589 46 82 Fax : (93) 589 04 46 URL : http://www.icomspain.com
Unit 9, Sea St., Herne Bay, Kent, CT6 8LD, U.K. Phone : 01227 741741 Fax : 01227 741742 URL : http://www.icomuk.co.uk
Zac de la Plaine, Rue Brindejonc des Moulinais BP 5804, 31505 Toulouse Cedex, France Phone : 561 36 03 03 Fax : 561 36 03 00 URL : http://www.icom-france.com
6-9-16, Kamihigashi, Hirano-ku, Osaka, 547-0002, Japan
A-5505I-S Printed in Japan © 1998 by Icom Inc.
View more...
Comments
