Coduri Eroare Man

DATA COMPENDIUM

FAULT MESSAGES

TRUCKNOLOGY GENERATION

SD 812a en-online 05.2007 Page 1 of 276

For notes on setting or repairing the individual systems please see the repair manuals or the relevant Service Information sheets. After completing repairs delete the fault memory. The last page folds out; on the inside you will find the FMI code and its meaning. The SPN for the door module – driver's and co-driver's side – can be read out only with MAN-cats II; the SPN is not shown in the display. If one SPN refers to the same fault/component in several control units/systems, only the generic term of the system is given. Example: "03512 EBS OBD, request, red warning lamp for diagnosis": this SPN applies to all EBS variants although they are not all expressly named (EBS2, EBS5 etc.) Ifo ne SPN refers to different fauls/components in several control units/systems each relevant variant is named. Example: 03099 EDC (Common Rail) fuel pressure sensor – rail pressure 03099 EDC (no Common Rail) fuel pressure sensor

This SD supersedes SD 812-08.2001 © 2007 MAN Nutzfahrzeuge Aktiengesellschaft VAST, mr 05.2007 SD 812a en-online 05.2007 Page 2 of 276

Main instrument Message in display

SD 812a en-online 05.2007 Page 3 of 276

Message via check lamp panels

Display Text in display ABS in trailer ABS in trailer, failure ABS in tractor, failure CAN network failure ASR failure

Check LED lamp panel yellow yellow yellow yellow yellow

Buzzeryes yes

Remarks Line to trailer ABS to earth, fault in trailer ABS or trailer ABS speed sensor test Power supply to trailer ABS is not between 100mA and 2A

yes

ABS function is restricted

yes

Reaction stored in instrument

yes

Connection to engine control unit disrupted

EBS failure

red

yes

EBS not on CAN

Reservoir pressure too low

red

yes

Pressure is below warning pressure ECAM substitute function in ZBR

Reservoir pressure K1

red

yes

Reservoir pressure K2

red

yes

Reservoir pressure K3

red

yes

Reservoir pressure K4

red

yes

SD 812a en-online 05.2007 Page 4 of 276

Reservoir pressure implausible, shown only with ECAM

Check LED lamp panel

Buzzer-

Reservoir pressure K1 too low

red

yes

Reservoir pressure K2 too low

red

yes

Reservoir pressure K3 too low

red

yes

Reservoir pressure K4 too low

red

yes

ECAM failure

red

yes

ECAM not on CAN

Fault in trailer brake

red

yes

CAN brake, tractor to trailer

CAN network failure

red

yes

Reaction saved in instruments

Brake pads/linings warn

red

yes

INFO Not driving level

yellow

yes

No valid ride level set

ECAS failure

red

yes

ECAS not on CAN

Lock cab!

red

yes

Tipper operation

red

yes

Display Text in display

Remarks Pressure below warning pressure or ECAM substitute function in ZBR or short-circuit/interruption in sensor/sensor cable or pressure constantly below reservoir pressure

At least one of switching contacts for cab lock is open Cable from tipper switch contact to earth SD 812a en-online 05.2007 Page 5 of 276

Check LED lamp panel

Buzzer-

Remarks

Lock liftgate

red

yes

Cable from liftgate switch to High Potential

Gas filter contaminated

red

yes

Comfort Shift defective

red

yes

Comfort Shift cannot be used

Reservoir pressure – do not shift

red

yes

No reservoir pressure on gearbox

Gearbox temp. too high

red

yes

Gearbox temp. much too high

yes

Partial vacuum has exceeded limit

Display Text in display

Oil pressure too low Oil pressure too high

yellow red red

Coolant level too low

red

yes

Cooling system

red

yes

Gradient for coolant > 102° C too high

red

yes

To EDC anti-boiling feature

red

yes

Engine speed too high

red

yes

EDC speed monitoring

Engine brake failure

red

yes

EGR valve above/below position

Change air filter

Cooling system – switch off engine Coolant temp. too high

SD 812a en-online 05.2007 Page 6 of 276

yes yes

Check LED lamp panel

Buzzer-

Engine oil temp. too high

red

yes

ESP failure

yellow

yes

ESP no onCAN or CAN message with ESP contents is missing

ESP failure

yellow

yes

FDR function is restricted or not present

Display Text in display

-

No text

-

No text

-

No text

-

No text

-

No text

-

yellow yellow yellow yellow

no yes yes

Remarks

ABS switch-off or ABS OFFROAD Reaction in instrument saved on CAN in event of failure Reaction in instrument saved on CAN in event of failure

no

No ABS on trailer

red

no

Comes on when ignition is switched on, remains on after bulb test ,

No text

red

no

Cable for belt check is on earth

No text

yellow

no

ASR intervention (LED comes on) or ASR OFFROAD (LED flashes) SD 812a en-online 05.2007 Page 7 of 276

Display Text in display

Check LED lamp panel

Buzzer-

Remarks

-

No text

grün

no

Flasher check for trailer

-

No text

yellow

no

ESP (FDR) interventions

-

No text

blau

no

High beam function check

-

No text

red

no

Parking brake function check

-

No text

no

Flame start function check

-

No text

yellow yellow

no

Overload on rear axle or overload on front axle

-

-

yes

Level not reached

-

-

yes

Ride level implausible or cannot be set by ECAS

TCO failure

-

-

yes

EU tachograph not on CAN

Check TCO

-

-

yes

EU tachograph not in order.

Brake lights without function

-

-

yes

Brake light signal failure on CAN

SD 812a en-online 05.2007 Page 8 of 276

Display Text in display

Check LED lamp panel

Buzzer-

Tractor brake lights failure

-

-

yes

Trailer brake lights failure

-

-

yes

-

-

yes

-

-

yes

Clear lighting monitoring

-

-

no

Block lighting monitoring

-

-

no

Flasher test

-

-

no

Light test

-

-

no

Light test aborted

-

-

no

Light test again

-

-

no

End of light test

-

-

no

Trailer flashers rh failure or Trailer flashers lh failure Tractor flashers rh failure or Tractor flashers lh failure

Remarks Lamp defective short-circuit, cable interrupted Lamp defective short-circuit, cable interrupted Failure of flasher lamp, or lamp load out of tolerance

SD 812a en-online 05.2007 Page 9 of 276

Display Text in display

Check LED lamp panel

Buzzer-

Remarks

New trailer, learn light test

-

-

no

High beam rh failure or high beam lh failure

-

-

yes

Add. headlight failure

-

-

yes

-

-

yes

-

-

yes

-

-

yes

-

-

yes

Failure of at least one side marker light on tractor

-

-

yes

Relay for parking lights (ZBR output)

-

-

yes

-

-

yes

-

-

yes

Add. headlight lh failure or Add. headlight rh failure Foglamp lh failure or Foglamp rh failure Rear foglamp failure on tractor rear foglamp failure on trailer Fault in lh side marker lights or fault in rh side marker lights Parking lights failure Trailer parking lights lh failure or trailer parking lights rh failure Tractor parking lights lh failure or tractor parking lights rh failure Winter service lighting failure SD 812a en-online 05.2007 Page 10 of 276

Relay for add. high beam (roof)

Relay for winter service cannot be triggered

Display Text in display

Check LED lamp panel

Buzzer-

Switch defective - foglamps

-

-

yes

Switch defective – low beam

-

-

yes

Switch defective – high beam

-

-

yes

Switch defective – headlight flash

-

-

yes

Switch defective – parking lights

-

-

yes

Brake pad/lining wear

-

yellow

yes

Parking brake display defective

-

-

yes

Apply parking brake

-

-

yes

Pre-glow

-

-

yes

Pre-glow again

-

-

yes

Start engine

-

-

yes

Remarks

Limit of wear reached in at least one brake lining/pad Parking brake display not possible, as CAN signal not available Refers to pre-glow period Shows that readiness for starting has expired, pre-glow must be repeated Refers to readiness for starting SD 812a en-online 05.2007 Page 11 of 276

Display Text in display Flammstart Ausfall

Check LED lamp panel -

Buzzeryes

Remarks

Danger black ice

-

-

yes

Refers to black ice

Clutch lining worn

-

-

yes

Limit of wear for clutch lining

Clutch overloaded – shift down

-

-

yes

Load too high during moving off

Actuate clutch

-

-

yes

Clutch did not open during shifting

Clutch oil level too low

-

-

yes

Clutch fluid level too low

Alternator display defective

-

-

yes

Alternator failure

-

-

yes

Charge voltage too low

-

-

yes

Tension V-belts

-

-

yes

Charge voltage too high

-

-

yes

Battery undervoltage

-

-

yes

Switch defective – warning flashers

-

-

yes

SD 812a en-online 05.2007 Page 12 of 276

When ignition is on cable from terminal L is not on earth Terminal L is on earth and engine running Charge voltage constantly too low At rated speed (engine) charge voltage is too high Battery undervoltage after standing too long

Display Text in display

Check LED lamp panel

Buzzer-

Remarks

Service due

-

-

yes

TBM failure

-

-

yes

TBM not on CAN

Apply parking brake

-

-

yes

Tells you to apply parking brake

Engage neutral

-

-

yes

Tells you to shift gearbox to neutral

SET xxkm/h

-

-

no

MEMO xxkm/h

-

-

no

LIMIT

-

-

no

-

-

yes

-

-

yes

Boost pressure sensor defective

-

-

yes

No text

-

-

no

FFR failure

-

-

yes

EDC not on CAN Boost pressure cannot be measured correctly Engine brake (in vehicles without retarder) FFR not on CAN

LGS failure

-

-

yes

LGS not on CAN

Info ! Fault or grease fault in central lube EDC failure

SD 812a en-online 05.2007 Page 13 of 276

Display Text in display KSM failure

Check LED lamp panel -

Buzzeryes

Remarks KSM not on CAN Engine brake (in vehicles with retarder) Primary retarder (water pump) not on CAN

No text

-

-

no

RET P failure

-

-

yes

RET S failure

-

-

yes

Secondary retarder not on CAN

Retarder temp. too high

-

-

yes

Oil temperature at retarder outlet too high (advance warning)

Retarder temp. too high

-

-

yes

Retarder temp. much too high

No text

-

-

no

CAN Verbund Ausfall

-

-

yes

T-CAN BusOff, Reaction saved in instruments

Low beam lh failure or low beam rh failure

-

-

yes

Low beam lh on tractor

Headlight height lh failure autom.

-

-

yes

Headlight height rh failure autom.

-

-

yes

Steering oil level fault

-

-

yes

SD 812a en-online 05.2007 Page 14 of 276

Automatic beam regulator implausible on lh side Automatic beam regulator implausible on rh side Oil level too low

Display Text in display

Check LED lamp panel

Buzzer-

Remarks

Steering oil pressure too low

-

-

yes

Switch for flow meter in emerg. steering pump is closed

TCU failure

-

-

yes

Automatic gearbox not on CAN

Comfort Shift defective

-

-

yes

Engage higher gear

-

-

yes

No idle gas

-

-

yes

Tells you to take foot off accelerator

Gearbox temp. too high

-

-

yes

Temperature in gearbox oil sump (advance warning)

Fill tank

-

-

yes

Tank on reserve

Tank pickup failure

-

-

yes

Monitoring of tank pickup 1 in ZBR

Tank pickup 2 failure

-

-

yes

Monitoring of tank pickup 2 in ZBR

Coolant level too low

-

-

yes

Coolant level below min.

No text

-

-

no

No text

-

-

no

Comfort Shift button is not being evaluated Speed difference between engine and gearbox too high

Function feedback from rear foglamp SD 812a en-online 05.2007 Page 15 of 276

Display Text in display

Check LED lamp panel

Buzzer-

No text

-

-

no

No text

-

-

no

No text

SD 812a en-online 05.2007 Page 16 of 276

-

-

no

Remarks

Display message for moving-off aid ECAS Nordland or ECAS EFR Nordland

Abbreviations Adaptive Cruise Control .................................................................... ACC Exhaust-gas recirculation ................................................................. EGR Arithmetic Logic Unit .......................................................................... ALU AS-Tronic ........................................................................................... AST Service brake valve ...........................................................................BBV Belt tensioner ....................................................................................... BT Control unit network.......................................................................... CAN Cruise Control Vehicle Speed ........................................................ CCVS Continuously Regenerating Trap (catalytic converter).......................CRT Comfort Shift ........................................................................................ CS Butterfly valve stipulation (adjustment angle) ....................................DKV Diagnostic message .......................................................................... DM Drive Neutral Reverse (selector lever/switches for autom. gearbox) DNR Pressure before radiator .................................................................... DvK Speed pickup .................................................................................... DZG Electronic Brake System....................................................................EBS Electronically Controlled Air Management......................................ECAM Electronically Controlled Air Suspension (applies to trucks and afterbody of articulated buses) .................... ECAS Electronically Controlled Air Suspension (applies to forebody of articulated buses)..................................... ECAS2 Eelctronic control unit ....................................................................... ECU Electronic Diesel Control .................................................................. EDC Final speed control ........................................................................... EDR Electronic Engine Controller ..............................................................EEC Electrically programmable non-volatile read-only memory ....... EEPROM Exhaust gas recirculation.................................................................. EGR Electrohydraulic steering system .....................................................EHLA AS-Tronic lite ................................................................................. EMOS End of Line programming ..................................................................EOL Electronic Transmission Control ........................................................ETC Exhaust Valve Brake .........................................................................EVB Ride dynamics control .......................................................................FDR Vehicle management computer ......................................................... FFR Road speed limiter .............................................................................FGB Road speed control........................................................................... FGR SD 812a en-online 05.2007 Page 17 of 276

Failure mode identification (fault type)................................................FMI Closed-loop diesel catalyst ............................................................... GDK Behr air-conditioner control............................................................... GKR Urea metering system....................................................................... HDS Hydraulic front axle drive (HydroDrive)..............................................HVA Auxiliary speed pickup ...................................................................... HZG Integrated circuit ................................................................................... IC CAN-connection between the two processors in main instrument ...............................................................................ICOM Identification.......................................................................................... ID Instrument .........................................................................................INST Intarder................................................................................................ INT Customer-specific module ................................................................ KSM Message from customer-specific module .......................................KSMA Temperature sensor .......................................................................... KTY Data transfer protocol MAN-cats II ...........................................KWP2000 Lane Guard System ...........................................................................LGS Local Identifier .................................................................................... LID Idling speed ....................................................................................... LLR Microprocessor .................................................................................... µC Delivery control rack ......................................................................... MES Modular door control ......................................................................... MTS On-board diagnostic unit.................................................................OBDU Parameter group number.................................................................. PGN Pulse width modulation.................................................................... PWM Rear Axle Steering.............................................................................RAS Central tyre inflation system ...........................................................RDRA Secondary retarder ..........................................................................Ret-S Primary retarder ...............................................................................Ret-P Ship vehicle management computer ...............................................SFFR Side marker light ...............................................................................SML Suspect Parameter Number ..............................................................SPN Headlight cleaning system................................................................SWR Telematic Board Module ................................................................... TBM EU tachograph .................................................................................. TCO Gearbox control unit ..........................................................................TCU Torque speed control (brake torque) .................................................TSC Central on-board computer................................................................ZBR Intermediate speed control ................................................................ZDR SD 812a en-online 05.2007 Page 18 of 276

FMI 0 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15

Definition No fault Fault saved Intermittent fault Fault is present and saved Fault not specified Too high Too low Implausible No signal present Short-circuit to earth Short-circuit to UBatt. Short-circuit Fault signal Fault in component Interruption Not defined Not defined Not defined Not defined Not defined

SD 812a en-online 05.2007 Page 19 of 276

SPN 00000 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001

Control unit/System MTS AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR

SD 812a en-online 05.2007

Fault message Base module Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Expansion module door 2 Date, time, mileage in km Road speed Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Page 20 of 276

SPN 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00001 00002 00002 00003 00003 00004 00004 00005 00005 00006 00006 00007 00007 00008 00008 00009 00009 00010 00010 00011 00011 00012 00012 00013 00013 00014 00014 00015 00015 00016 00017 00018 00019 00020 00021 00022 00023

Control unit/System SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c MTS OUZBRO MTS OUZBRO MTS OUZBRO MTS OUZBRO MTS OUZBRO MTS OUZBRO MTS OUZBRO MTS OUZBRO MTS OUZBRO MTS OUZBRO MTS OUZBRO MTS OUZBRO MTS OUZBRO MTS OUZBRO MTS MTS MTS MTS MTS MTS MTS MTS

SD 812a en-online 05.2007

Fault message Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Date, time, mileage in km Expansion module door 3 Engine revs Expansion module door 4 Oil pressure Expansion module door 5 Reservoir pressure brake circuit 1 Motor/door valve door 1 (front) Reservoir pressure brake circuit 2 Motor/door valve door 1 (rear) Brake pressure brake circuit 1 Motor/door valve door 2 (front) Brake pressure brake circuit 2 Motor/door valve door 1 (rear) Accelerator pedal position Motor/door valve door 3 (front) Preselected gear Motor/door valve door 3 (rear) Engaged gear Motor/door valve door 4 (front) Cooling water temperature Motor/door valve door 4 (rear) Tank fill level Motor/door valve door 5 (front) Reservoir pressure brake circuit 1 Motor/door valve door 5 (rear) Reservoir pressure brake circuit 2 Entry lighting door 1 On-board voltage Entry lighting door 2 Entry lighting door 3 Entry lighting door 4 Entry lighting door 5 Door closing warning device door 1 Door closing warning device door 2 Door closing warning device door 3 Door closing warning device door 4 Page 21 of 276

SPN 00024 00025 00026 00027 00028 00029 00030 00031 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032

Control unit/System MTS MTS MTS MTS MTS MTS MTS MTS AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS

SD 812a en-online 05.2007

Fault message Door closing warning device door 5 Ramp activation door 1 Ramp activation door 2 Ramp activation door 3 Ramp activation door 4 Ramp activation door 5 Stop request display door 1 Stop request display door 2 Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Stop request display door 3 Page 22 of 276

SPN 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00032 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033

Control unit/System OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M

SD 812a en-online 05.2007

Fault message Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Split position Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Page 23 of 276

SPN 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00033 00034 00035 00036 00037 00038 00038

Control unit/System EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c MTS MTS MTS MTS AB ACC

SD 812a en-online 05.2007

Fault message Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Stop request display door 4 Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Clutch travel sensor Stop request display door 5 Door enable display door 1 Door enable display door 2 Door enable display door 3 Fuel fill level 2 Fuel fill level 2 Page 24 of 276

SPN 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038

Control unit/System AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C

SD 812a en-online 05.2007

Fault message Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Door enable display door 4 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Page 25 of 276

SPN 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00038 00039 00040 00041 00042 00043 00044 00045 00046 00046 00047 00048 00049 00050 00051 00051 00052 00053 00054 00055 00056 00057 00058 00059 00060 00061 00062 00063 00064 00065 00066 00067 00068 00069 00070 00070 00070 00071 00072 00073

Control unit/System TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c MTS MTS MTS MTS MTS MTS MTS EMOS MTS MTS MTS MTS MTS CNG_ME7 MTS MTS MTS MTS MTS MTS MTS MTS MTS MTS MTS MTS MTS MTS MTS MTS MTS MTS MTS MTS OBDU ZBR2 MTS MTS MTS

SD 812a en-online 05.2007

Fault message Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Second Fuel Level (Right Side) Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Fuel fill level 2 Door enable display door 5 Workshop switch door 1 Workshop switch door 2 Workshop switch door 3 Workshop switch door 4 Workshop switch door 5 Pressure shaft door 1 Cruise control nominal speed Pressure shaft door 2 Pressure shaft door 3 Pressure shaft door 4 Pressure shaft door 5 Stop request button door 1 Throttle butterfly Stop request button door 2 Stop request button door 3 Stop request button door 4 Stop request button door 5 Baby carriage button door 1 Baby carriage button door 2 Baby carriage button door 3 Baby carriage button door 4 Baby carriage button door 5 Limit switch CLOSED door 1 (front) Limit switch CLOSED door 1 (rear) Limit switch CLOSED door 2 (front) Limit switch CLOSED door 2 (rear) Limit switch CLOSED door 3 (front) Limit switch CLOSED door 3 (rear) Limit switch CLOSED door 4 (front) Limit switch CLOSED door 4 (rear) Limit switch CLOSED door 5 (front) Limit switch CLOSED door 5 (rear) Pressure monitoring door 1 Parking brake applied No 'parking brake' signal Pressure monitoring door 2 Pressure monitoring door 3 Pressure monitoring door 4 Page 26 of 276

SPN 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074

Control unit/System AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG

SD 812a en-online 05.2007

Fault message Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Pressure monitoring door 5 Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Page 27 of 276

SPN 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00074 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075

Control unit/System STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10

SD 812a en-online 05.2007

Fault message Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Lamp, road speed limiting Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Page 28 of 276

SPN 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00075 00076 00077 00078 00079 00080 00081 00081 00082 00083 00084 00084 00084 00084 00084

Control unit/System EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c MTS MTS MTS MTS MTS EDC7 MTS MTS MTS AB ACC AST ASTMID BHTC

SD 812a en-online 05.2007

Fault message Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Reference voltage door sensors door 1 Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Steering axle temperature Reference voltage door sensors door 2 Reference voltage door sensors door 3 Reference voltage door sensors door 4 Reference voltage door sensors door 5 Door sensor door 1 front Exhaust gas differential or exhaust gas relative pressure Door sensor door 1 rear Door sensor door 2 front Door sensor door 2 rear wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed Page 29 of 276

SPN 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084

Control unit/System CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module

SD 812a en-online 05.2007

Fault message wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed Door sensor door 3 front wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed Rear axle speed sensor wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed Page 30 of 276

SPN 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00084 00085 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086

Control unit/System TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c MTS AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR

SD 812a en-online 05.2007

Fault message wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed wheel-based vehicle speed Door sensor door 3 rear Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Page 31 of 276

SPN 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00086 00087 00088 00089 00090 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091

Control unit/System GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c MTS MTS MTS MTS AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV

SD 812a en-online 05.2007

Fault message Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Door sensor door 4 front Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Road speed, cruise control Door sensor door 4 rear Door sensor door 5 front Door sensor door 5 rear C3 signal Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Page 32 of 276

SPN 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091 00091

Control unit/System ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK

SD 812a en-online 05.2007

Fault message Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal angle signal Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Checklamp driver's workplace Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Page 33 of 276

SPN 00091 00091 00091 00091 00091 00091 00091 00091 00091 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092

Control unit/System ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA

00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092

EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM

SD 812a en-online 05.2007

Fault message Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Accelerator pedal position Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Relative engine torque signal, in relation to the current max. available engine torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Page 34 of 276

SPN 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00092 00094 00094 00095 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096

Control unit/System LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c EDC7 MTS MTS AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64

SD 812a en-online 05.2007

Fault message Current torque to maximum torque Pneumatic seal Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Current torque to maximum torque Fuel supply pressure Red/green display Depressurised buzzer Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Page 35 of 276

SPN 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00096 00097

Control unit/System EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c MTS

SD 812a en-online 05.2007

Fault message Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Bus-stop brake Fuel Level Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel Level Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Fuel fill level 1 Stop request display driver Page 36 of 276

SPN 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098

Control unit/System AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG

SD 812a en-online 05.2007

Fault message Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Baby carriage display driver Oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Page 37 of 276

SPN 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00098 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100

Control unit/System STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10

SD 812a en-online 05.2007

Fault message Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Engine oil level Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Page 38 of 276

SPN 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00100 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102

Control unit/System EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV

SD 812a en-online 05.2007

Fault message Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Engine Oil Pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Oil pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Page 39 of 276

SPN 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102 00102

Control unit/System ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK

SD 812a en-online 05.2007

Fault message Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost Pressure Boost pressure Boost Pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Charge air pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Page 40 of 276

SPN 00102 00102 00102 00102 00102 00102 00102 00102 00102 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105

Control unit/System ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS

SD 812a en-online 05.2007

Fault message Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Boost pressure Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Boost air temperature sensor upstream of cylinder inlet Charge air temperature Boost air temperature sensor upstream of cylinder inlet Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Page 41 of 276

SPN 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00105 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107

Control unit/System MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6

SD 812a en-online 05.2007

Fault message Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Charge air temperature Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Charge air low pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Page 42 of 276

SPN 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00107 00108 00108 00108 00108 00108

Control unit/System EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC

SD 812a en-online 05.2007

Fault message Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Air filter pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Page 43 of 276

SPN 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108

Control unit/System CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module

SD 812a en-online 05.2007

Fault message Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Atmospheric pressure Barometric Pressure Atmospheric pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Page 44 of 276

SPN 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00108 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109

Control unit/System TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR

SD 812a en-online 05.2007

Fault message Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Barometric Pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Page 45 of 276

SPN 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00109 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110

Control unit/System HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M

SD 812a en-online 05.2007

Fault message Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Cooling water pressure Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Cooling water temperature Cooling water temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Page 46 of 276

SPN 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110 00110

Control unit/System EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580

SD 812a en-online 05.2007

Fault message Coolant temperature Coolant temperature Coolant temperature Cooling water temperature Coolant temperature Cooling water temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Cooling water temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Engine Coolant Temperature Coolant temperature Coolant temperature Coolant temperature Coolant temperature Page 47 of 276

SPN 00110 00110 00110 00110 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111

Control unit/System ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM

SD 812a en-online 05.2007

Fault message Coolant temperature Coolant temperature Coolant temperature Coolant temperature Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Page 48 of 276

SPN 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00111 00119 00120 00132 00157 00157 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158

Control unit/System RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c RET DIW5 CNG_ME7 EDC6 EDC7 AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6

SD 812a en-online 05.2007

Fault message Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Coolant Level Housing pressure Temperature acquisition retarder oil Air mass Fuel pressure Fuel pressure in rail Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Terminal 15 electrical power supply Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Page 49 of 276

SPN 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00158 00159 00159 00159 00159 00159

Control unit/System EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC

SD 812a en-online 05.2007

Fault message Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Supply voltage outside value range Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Ignition off Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Voltage terminal 15 Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Voltage terminal 15 Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Battery Potential (Voltage), Switched Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Page 50 of 276

SPN 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159

Control unit/System CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module

SD 812a en-online 05.2007

Fault message Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Page 51 of 276

SPN 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00159 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161

Control unit/System TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR

SD 812a en-online 05.2007

Fault message Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gas Supply Pressure Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Page 52 of 276

SPN 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00161 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168

Control unit/System HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M

SD 812a en-online 05.2007

Fault message Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Gearbox input speed Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage acquisition Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Page 53 of 276

SPN 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168

Control unit/System EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG

00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168 00168

STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR

SD 812a en-online 05.2007

Fault message Battery voltage Battery voltage Battery voltage Electricla Potential (Voltage) Battery voltage acquisition Electricla Potential (Voltage) Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Electricla Potential (Voltage) Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Voltage terminal 30 Battery voltage Battery voltage Undervoltage in on-board voltage (TL. 30) see MAN standard M3332/start voltage drop Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Electricla Potential (Voltage) Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Tl. 30-0 not connected Battery voltage Battery voltage Battery voltage Page 54 of 276

SPN 00168 00168 00168 00168 00168 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171

Control unit/System ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R

SD 812a en-online 05.2007

Fault message Battery voltage Battery voltage Battery voltage Battery voltage Battery voltage Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Page 55 of 276

SPN 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00171 00173 00173 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174

Control unit/System PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c CNG_ME7 EDC7 AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S

SD 812a en-online 05.2007

Fault message Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Outside temperature Exhaust temperature sensor Exhaust temperature before exhaust post-treatment Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Gas temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Page 56 of 276

SPN 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00174 00175 00175 00175 00175 00175 00175 00175

Control unit/System EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT

SD 812a en-online 05.2007

Fault message Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Fuel temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Page 57 of 276

SPN 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175

Control unit/System DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON

SD 812a en-online 05.2007

Fault message Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine cooling water temperature signal Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Page 58 of 276

SPN 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00175 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177

Control unit/System TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ

SD 812a en-online 05.2007

Fault message Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Engine oil temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Gear oil temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Page 59 of 276

SPN 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00177 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190

Control unit/System HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S

SD 812a en-online 05.2007

Fault message Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Transmission fluid temperature Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed acquisition Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Page 60 of 276

SPN 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190 00190

Control unit/System EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC

SD 812a en-online 05.2007

Fault message Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed signal Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Engine speed Page 61 of 276

SPN 00190 00190 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191

Control unit/System ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET

SD 812a en-online 05.2007

Fault message Engine speed Engine speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed acquisition Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Page 62 of 276

SPN 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00191 00228 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245

Control unit/System SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c RAS AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12

SD 812a en-online 05.2007

Fault message Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Gearbox output speed Speed speedometer and sensor Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Page 63 of 276

SPN 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00245 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359

Control unit/System EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1

SD 812a en-online 05.2007

Fault message Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Vehicle mileage Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Page 64 of 276

SPN 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359

Control unit/System ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV

SD 812a en-online 05.2007

Fault message Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Page 65 of 276

SPN 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00359 00512 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513

Control unit/System VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c EMOS AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST

SD 812a en-online 05.2007

Fault message Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Kickdown switch signal Driver request torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque signal Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Page 66 of 276

SPN 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00513 00514 00514 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518

Control unit/System INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c CRT EMOS AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE

SD 812a en-online 05.2007

Fault message Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Engine torque Friction torque 'Engine friction loss moment' signal Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Torque limiting rated torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Page 67 of 276

SPN 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518 00518

Control unit/System EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a

SD 812a en-online 05.2007

Fault message FFR2: Bit error, torque limitation Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Requested Torque Page 68 of 276

SPN 00518 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520

Control unit/System ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR

SD 812a en-online 05.2007

Fault message Requested Torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Engine brake torque signal Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Page 69 of 276

SPN 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00520 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521

Control unit/System SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12

SD 812a en-online 05.2007

Fault message Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Actual Retarder - Percent Torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Current retarder torque Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Page 70 of 276

SPN 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00521 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523

Control unit/System EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2

SD 812a en-online 05.2007

Fault message Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Brake pedal setting Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Page 71 of 276

SPN 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523

Control unit/System ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM

SD 812a en-online 05.2007

Fault message Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Page 72 of 276

SPN 00523 00523 00523 00523 00523 00523 00523 00523 00523 00523 00525 00544 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556

Control unit/System WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c EMOS CRT AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT

SD 812a en-online 05.2007

Fault message Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Current gear Nominal gear signal Faulty engine speed signal Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Page 73 of 276

SPN 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00556 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558

Control unit/System KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7

SD 812a en-online 05.2007

Fault message Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Reference torque of the retarder Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Page 74 of 276

SPN 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00558 00559 00560

Control unit/System EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c EMOS CRT

SD 812a en-online 05.2007

Fault message Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Unladen driving switch signal Kickdown signal active CAN message ETC 1 Page 75 of 276

SPN 00560 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561

Control unit/System VSM AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR

SD 812a en-online 05.2007

Fault message ETC1 message, 'Driveline closed' signal ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch Signal for engine intervention by ASR ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch Page 76 of 276

SPN 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00561 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562

Control unit/System SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12

SD 812a en-online 05.2007

Fault message ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR engine check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch Page 77 of 276

SPN 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00562 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563

Control unit/System EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2

SD 812a en-online 05.2007

Fault message ASR brake check switch ASR brake check switch ASR brake check switch Signal for brake intervention by ASR ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ASR brake check switch ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal Page 78 of 276

SPN 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563

Control unit/System ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM

SD 812a en-online 05.2007

Fault message ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal Page 79 of 276

SPN 00563 00563 00563 00563 00563 00563 00563 00563 00563 00563 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572

Control unit/System WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM

SD 812a en-online 05.2007

Fault message ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal ABS active signal Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Page 80 of 276

SPN 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00572 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578

Control unit/System LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32

SD 812a en-online 05.2007

Fault message Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Retarder switch shift assistant Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Page 81 of 276

SPN 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00578 00582 00582 00582 00582

Control unit/System EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID

SD 812a en-online 05.2007

Fault message Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Rear axle temperature Axle load Axle load Axle load Axle load Page 82 of 276

SPN 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582

Control unit/System BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module

SD 812a en-online 05.2007

Fault message Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Page 83 of 276

SPN 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00582 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595

Control unit/System Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR

SD 812a en-online 05.2007

Fault message Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Axle load Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Page 84 of 276

SPN 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00595 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597

Control unit/System GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7

SD 812a en-online 05.2007

Fault message Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Cruise control active signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Pedal brake module switch 1 Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Page 85 of 276

SPN 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597 00597

Control unit/System EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR

SD 812a en-online 05.2007

Fault message Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal No Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal No Brake switch signal Brake switch signal Brake switch signal Page 86 of 276

SPN 00597 00597 00597 00597 00597 00598 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601

Control unit/System ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c KSM AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO

SD 812a en-online 05.2007

Fault message Brake switch signal Brake switch signal Brake switch signal Brake switch signal Brake switch signal Clutch switch signal Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Page 87 of 276

SPN 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00601 00603 00609 00609 00609 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617

Control unit/System OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c EBS_5 EBS_5 EDC6 EDC7 AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32

SD 812a en-online 05.2007

Fault message Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Road speed governor resume switch Pedal brake module switch 2 Central control unit - B-controller Engine CAN Engine CAN Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Page 88 of 276

SPN 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00617 00620 00627 00627 00629

Control unit/System EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c RAS EBS_5 RAS AB

SD 812a en-online 05.2007

Fault message Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Parking brake output Electrical power supply to steering angle sensors Monitoring of voltage supply on PIN X1/16 - X1/17 Voltage supply terminal 30 Control unit Page 89 of 276

SPN 00629 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637

Control unit/System EBS_5 AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR

SD 812a en-online 05.2007

Fault message Central control unit - A-controller Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Page 90 of 276

SPN 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00637 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638

Control unit/System SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12

SD 812a en-online 05.2007

Fault message Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Timing Sensor Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Page 91 of 276

SPN 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00638 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639

Control unit/System EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2

SD 812a en-online 05.2007

Fault message Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Rack Actuator Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link J1939 (driveline CAN) Sae J1939 Data Link Sae J1939 Data Link CAN bus off Page 92 of 276

SPN 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639

Control unit/System ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM

SD 812a en-online 05.2007

Fault message Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Driveline CAN short circuit Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link T-CAN busoff Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link CAN bus malfunction Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link CAN error Sae J1939 Data Link Sae J1939 Data Link CAN bus malfunction Sae J1939 Data Link Page 93 of 276

SPN 00639 00639 00639 00639 00639 00639 00639 00639 00639 00639

Control unit/System WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c

00645 00645 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647

EBS_5 RAS AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST

SD 812a en-online 05.2007

Fault message Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link Sae J1939 Data Link External sequential fault: Time overrun or fault condition in communication with tachograph on CAN (SA=0xEE) Speedometer signal Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Page 94 of 276

SPN 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00647 00648 00651

Control unit/System INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c FFR CNG_ME7

00651 00652

EDC7 CNG_ME7

00652 00653

EDC7 CNG_ME7

00653 00654

EDC7 CNG_ME7

00654 00655

EDC7 CNG_ME7

00655

EDC7

SD 812a en-online 05.2007

Fault message Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan clutch Fan speed sensor Injection valve of cylinder 1 4-cylinder engine: Cyl. 1; 6-cylinder engine: Cyl. 1; 8-cylinder engine: Master cyl. 1, slave cyl. 5; 10-cylinder engine: Master cyl. 1, slave cyl. 6; 12-cylinder engine: Master cyl. 1, slave cyl. 12 Injection valve of cylinder 2 4-cylinder engine: Cyl. 3; 6-cylinder engine: Cyl. 5; 8-cylinder engine: Master cyl. 2, slave cyl. 7; 10-cylinder engine: Master cyl. 5, slave cyl. 10; 12-cylinder engine: Master cyl. 5, slave cyl. 8 Injection valve of cylinder 3 4-cylinder engine: Cyl. 4; 6-cylinder engine: Cyl. 3; 8-cylinder engine: Master cyl. 3, slave cyl. 6; 10-cylinder engine: Master cyl. 2, slave cyl. 7; 12-cylinder engine: Master cyl. 3, slave cyl. 10 Injection valve of cylinder 4 4-cylinder engine: Cyl. 2; 6-cylinder engine: Cyl. 6; 8-cylinder engine: Master cyl. 4, slave cyl. 8; 10-cylinder engine: Master cyl. 3, slave cyl. 8; 12-cylinder engine: Master cyl. 6, slave cyl. 7 Injection valve of cylinder 5 6-cylinder engine: Cyl. 2; 10-cylinder engine: Master cyl. 4, slave cyl. 9; 12-cylinder engine: Master cyl. 2, slave cyl. 11 Page 95 of 276

SPN 00656

Control unit/System CNG_ME7

00656 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697

EDC7 AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS

SD 812a en-online 05.2007

Fault message Injection valve of cylinder 6 6-cylinder engine: Cyl. 4; 12-cylinder engine: Master cyl. 4, slave cyl. 9 Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Page 96 of 276

SPN 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00697 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698

Control unit/System RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12

SD 812a en-online 05.2007

Fault message Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM1 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Page 97 of 276

SPN 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00698 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699

Control unit/System EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1

SD 812a en-online 05.2007

Fault message Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Page 98 of 276

SPN 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699

Control unit/System ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV

SD 812a en-online 05.2007

Fault message Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Page 99 of 276

SPN 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699 00699

Control unit/System VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c

00701 00702 00702 00703

VSM KSM VSM KSM

00703 00704 00704 00705 00705 00706 00706 00707 00707 00708 00708 00709 00711 00711 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723

VSM KSM VSM KSM VSM KSM VSM KSM VSM KSM VSM KSM EDC6 EDC7 AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6

SD 812a en-online 05.2007

Fault message Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Accelerator pedal PWM1 and PWM2 signal Output stage 'Request for drive programme 2 of Ecomat control unit' Earth switch output, adjustable parameters Output stage 'Request for off-road range in the transfer case' Switch terminal 30 output, adjustable parameters Output stage 'Request for neutral position in the transfer case' Switch 2 terminal 30 output, adjustable parameters Output stage 'Request for on-road range in the transfer case' Switch 3 terminal 30 output, adjustable parameters Output stage 'Request for rear axle transverse lock' Switch 4 terminal 30 output, adjustable parameters Output stage 'Request for front axle transverse lock' Switch 5 terminal 30 output, adjustable parameters Output stage 'Request for transfer case interaxle lock' Earth switch 2 output, adjustable parameters Output stage 'Request for rear axle interaxle lock' Earth switch 3 output, adjustable parameters Duration of main injection Duration of main injection Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Page 100 of 276

SPN 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00723 00731 00734 00734 00734 00734

Control unit/System EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c CNG_ME7 AB ACC AST ASTMID

SD 812a en-online 05.2007

Fault message Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Auxiliary engine speed sensor Knock sensor 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Page 101 of 276

SPN 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734

Control unit/System BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module

SD 812a en-online 05.2007

Fault message Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Page 102 of 276

SPN 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00734 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735

Control unit/System Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR

SD 812a en-online 05.2007

Fault message Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 1 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Page 103 of 276

SPN 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00735 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736

Control unit/System GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7

SD 812a en-online 05.2007

Fault message Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 2 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Page 104 of 276

SPN 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736 00736

Control unit/System EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR

SD 812a en-online 05.2007

Fault message Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Page 105 of 276

SPN 00736 00736 00736 00736 00736 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737

Control unit/System ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R

SD 812a en-online 05.2007

Fault message Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 3 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Page 106 of 276

SPN 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00737 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738

Control unit/System PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12

SD 812a en-online 05.2007

Fault message Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve circuit 4 Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Page 107 of 276

SPN 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00738 00739 00739 00739 00739 00739 00739 00739 00739 00739

Control unit/System EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS

SD 812a en-online 05.2007

Fault message Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve pressure regulator Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Page 108 of 276

SPN 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739

Control unit/System EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR

SD 812a en-online 05.2007

Fault message Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Page 109 of 276

SPN 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00739 00743 00743 00744 00744 00746 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748

Control unit/System TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c RET VRET RET VRET EBS_5 AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR

SD 812a en-online 05.2007

Fault message Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration Solenoid valve regeneration On/off valve On/off valve Proportional valve Proportional valve Differential lock valve (differential lock switch) Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Page 110 of 276

SPN 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00748 00764 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767

Control unit/System GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c RET AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC

SD 812a en-online 05.2007

Fault message Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Retarder actuated Pressure sensor housing pressure Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Page 111 of 276

SPN 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767 00767

Control unit/System EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R

SD 812a en-online 05.2007

Fault message Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Page 112 of 276

SPN 00767 00767 00767 00767 00767 00767 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770

Control unit/System ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO

SD 812a en-online 05.2007

Fault message Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Transmission Reverse Direction Switch Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Page 113 of 276

SPN 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00770 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771

Control unit/System OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10

SD 812a en-online 05.2007

Fault message Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split H Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Page 114 of 276

SPN 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00771 00773 00773 00773 00773 00773 00773 00773 00773

Control unit/System EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5

SD 812a en-online 05.2007

Fault message Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L Split L DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch Page 115 of 276

SPN 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773

Control unit/System EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW

SD 812a en-online 05.2007

Fault message DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch Page 116 of 276

SPN 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00773 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780

Control unit/System TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA

SD 812a en-online 05.2007

Fault message DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch DNR switch Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Page 117 of 276

SPN 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00780 00789 00790 00791 00792 00793 00794 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833

Control unit/System HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c EBS_5 EBS_5 EBS_5 EBS_5 EBS_5 EBS_5 AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2

SD 812a en-online 05.2007

Fault message Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator Gearbox neutral indicator (!) Wheel sensor wheel 1 (!) Wheel sensor wheel 2 (!) Wheel sensor wheel 3 (!) Wheel sensor wheel 4 (!) Wheel sensor wheel 5 (!) Wheel sensor wheel 6 Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Page 118 of 276

SPN 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833 00833

Control unit/System EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO

SD 812a en-online 05.2007

Fault message Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Control path Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Page 119 of 276

SPN 00833 00833 00833 00833 00833 00833 00833 00835 00876 00877 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898

Control unit/System ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c RAS GKR GKR AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM

SD 812a en-online 05.2007

Fault message Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Fuel Rack Position Sensor Oil level signal Compressor coupling Evaporator temperature sensor Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Page 120 of 276

SPN 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00898 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904

Control unit/System LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32

SD 812a en-online 05.2007

Fault message Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Maximum speed limiter switch Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Page 121 of 276

SPN 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00904 00905 00906 00907 00908

Control unit/System EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c EMOS EMOS EMOS EMOS

SD 812a en-online 05.2007

Fault message Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Front axle speed Differential speed left front wheel Differential speed right front wheel Differential speed left rear wheel Differential speed right rear wheel Page 122 of 276

SPN 00929 00932 00933 00938 00939 00944 00946 00948 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959

Control unit/System TPM EBS_5 EBS_5 EBS_5 EBS_5 AB AB AB AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS

SD 812a en-online 05.2007

Fault message Tyre data Pressure regulating valve left intake valve Pressure regulating valve right intake valve Pressure regulating valve left exhaust valve Pressure regulating valve right exhaust valve Driver’s airbag (loop 1) left BT (loop 2) SRS lamp Seconds Seconds Seconds Seconds Seconds Seconds Seconds CAN message: Time/date, signal: Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds TIME/DATE: Seconds invalid Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Page 123 of 276

SPN 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00959 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960

Control unit/System OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M

SD 812a en-online 05.2007

Fault message Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Seconds Minutes Minutes Minutes Minutes Minutes Minutes Minutes CAN message: Time/date, signal: Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes TIME/DATE: Minutes invalid Minutes Minutes Minutes Minutes Minutes Minutes Page 124 of 276

SPN 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00960 00961 00961 00961 00961 00961 00961

Control unit/System EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7

SD 812a en-online 05.2007

Fault message Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Minutes Hours Hours Hours Hours Hours Hours Page 125 of 276

SPN 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961

Control unit/System CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM

SD 812a en-online 05.2007

Fault message Hours CAN message: Time/date, signal: Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours TIME/DATE: Hours invalid Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Page 126 of 276

SPN 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00961 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962

Control unit/System TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS

SD 812a en-online 05.2007

Fault message Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Hours Day Day Day Day Day Day Day CAN message: Time/date, signal: Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day TIME/DATE: Days invalid Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Page 127 of 276

SPN 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00962 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963

Control unit/System HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER

SD 812a en-online 05.2007

Fault message Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Day Month Month Month Month Month Month Month CAN message: Time/date, signal: Month Month Month Month Month Month Month Month Month Month Month Month Month Page 128 of 276

SPN 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963 00963

Control unit/System EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST

SD 812a en-online 05.2007

Fault message Month Month TIME/DATE: Months invalid Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Month Page 129 of 276

SPN 00963 00963 00963 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964

Control unit/System ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS

SD 812a en-online 05.2007

Fault message Month Month Month Year Year Year Year Year Year Year CAN message: Time/date, signal: Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year TIME/DATE: Year invalid Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Page 130 of 276

SPN 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00964 00974 00976 01007 01031 01042 01043

Control unit/System RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c KSM KSM ZBR2 ZBR2 EBS_5 ECAS_4X2

01045

AB

Gate interlock (auxiliary engines also brake lamp output stage)

01045

ACC

Gate interlock (auxiliary engines also brake lamp output stage)

01045

AST

Gate interlock (auxiliary engines also brake lamp output stage)

01045

ASTMID

Gate interlock (auxiliary engines also brake lamp output stage)

01045

BHTC

Gate interlock (auxiliary engines also brake lamp output stage)

01045

CNG_ME7

Gate interlock (auxiliary engines also brake lamp output stage)

01045

CRT

Gate interlock (auxiliary engines also brake lamp output stage)

01045

DIW5

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EBS

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EBS_5

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EBS_K1

Gate interlock (auxiliary engines also brake lamp output stage)

01045

ECAM

Gate interlock (auxiliary engines also brake lamp output stage)

01045

ECAS_4X2

Gate interlock (auxiliary engines also brake lamp output stage)

01045

ECAS2_GBV

Gate interlock (auxiliary engines also brake lamp output stage)

SD 812a en-online 05.2007

Fault message Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Year Pedal value sensor Ready output Trip Drive Fuel Used (Natural Gas) Trip Average Fuel Rate (Natural Gas) ISO 11992 (trailer CAN): Data bus switched off Supply voltage for peripherals

Page 131 of 276

SPN

Control unit/System

01045

ECAS2_GBW

Gate interlock (auxiliary engines also brake lamp output stage)

01045

ECO2

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC_7

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC_7_M

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC_7_MASTER

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC_7_S

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC_7_SLAVE

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC6

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC64

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC7

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC7_6

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC7C32

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC7C32_6

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC7C32_M

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC7C32_S

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC7C32M_10

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC7C32M_12

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC7C32S_10

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC7C32S_12

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC7M_10

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC7M_12

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC7S_10

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EDC7S_12

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EHLA

Gate interlock (auxiliary engines also brake lamp output stage)

01045

EMOS

Gate interlock (auxiliary engines also brake lamp output stage)

01045

FFR

Gate interlock (auxiliary engines also brake lamp output stage)

01045

GKR

Gate interlock (auxiliary engines also brake lamp output stage)

01045

HDS

Gate interlock (auxiliary engines also brake lamp output stage)

01045

HEITZ

Gate interlock (auxiliary engines also brake lamp output stage)

SD 812a en-online 05.2007

Fault message

Page 132 of 276

SPN

Control unit/System

01045

HVA

Gate interlock (auxiliary engines also brake lamp output stage)

01045

HYD

Gate interlock (auxiliary engines also brake lamp output stage)

01045

INST

Gate interlock (auxiliary engines also brake lamp output stage)

01045

INT

Gate interlock (auxiliary engines also brake lamp output stage)

01045

KR49X

Gate interlock (auxiliary engines also brake lamp output stage)

01045

KSM

Gate interlock (auxiliary engines also brake lamp output stage)

01045

LGS

Gate interlock (auxiliary engines also brake lamp output stage)

01045

MTS

Gate interlock (auxiliary engines also brake lamp output stage)

01045

OBDU

Gate interlock (auxiliary engines also brake lamp output stage)

01045

OUZBRO

Gate interlock (auxiliary engines also brake lamp output stage)

01045

OUZBRO_R

Gate interlock (auxiliary engines also brake lamp output stage)

01045

PTM

Gate interlock (auxiliary engines also brake lamp output stage)

01045

RAS

Gate interlock (auxiliary engines also brake lamp output stage)

01045

RET

Gate interlock (auxiliary engines also brake lamp output stage)

01045

SFFR

Gate interlock (auxiliary engines also brake lamp output stage)

01045

SKG

Gate interlock (auxiliary engines also brake lamp output stage)

01045

STON

Gate interlock (auxiliary engines also brake lamp output stage)

01045

T509C

Gate interlock (auxiliary engines also brake lamp output stage)

01045

TBM

Gate interlock (auxiliary engines also brake lamp output stage)

01045

Test1Module

Gate interlock (auxiliary engines also brake lamp output stage)

01045

Test2Module

Gate interlock (auxiliary engines also brake lamp output stage)

01045

TPM

Gate interlock (auxiliary engines also brake lamp output stage)

01045

TRON

Gate interlock (auxiliary engines also brake lamp output stage)

01045

TRW

Gate interlock (auxiliary engines also brake lamp output stage)

01045

TUER_DR

Gate interlock (auxiliary engines also brake lamp output stage)

01045

TUER_PA

Gate interlock (auxiliary engines also brake lamp output stage)

01045

UHV

Gate interlock (auxiliary engines also brake lamp output stage)

01045

VRET

Gate interlock (auxiliary engines also brake lamp output stage)

01045

VSM

Gate interlock (auxiliary engines also brake lamp output stage)

01045

WSK

Gate interlock (auxiliary engines also brake lamp output stage)

SD 812a en-online 05.2007

Fault message

Page 133 of 276

SPN

Control unit/System

01045

ZBR2

Gate interlock (auxiliary engines also brake lamp output stage)

01045

ZBRO

Gate interlock (auxiliary engines also brake lamp output stage)

01045

ZBRO_R

Gate interlock (auxiliary engines also brake lamp output stage)

01045

ZFR

Gate interlock (auxiliary engines also brake lamp output stage)

01045

ZH_AT3500_1580

Gate interlock (auxiliary engines also brake lamp output stage)

01045

ZH_AT3500_ST

Gate interlock (auxiliary engines also brake lamp output stage)

01045

ZH_D5W_SC

Gate interlock (auxiliary engines also brake lamp output stage)

01045

ZHZG_9a

Gate interlock (auxiliary engines also brake lamp output stage)

01045

ZHZG_9c

Gate interlock (auxiliary engines also brake lamp output stage)

01056

EBS_5

(!) Trailer control module pressure control, maximum pressure

01057 01058 01060 01061 01062 01063 01064 01065 01066 01067 01068 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072

EBS_5 EBS_5 EBS_5 EBS_5 EBS_5 EBS_5 EBS_5 EBS_5 EBS_5 EBS_5 EBS_5 AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32

SD 812a en-online 05.2007

Fault message

(!) Central control unit - B-controller: Implausible pressure from trailer control module pressure sensor, when brakes not applied Trailer control module - pressure sensor signal Brake pad wear sensor signal wheel 1 Brake pad wear sensor signal wheel 2 Brake pad wear sensor signal wheel 3 Brake pad wear sensor signal wheel 4 Brake pad wear sensor signal wheel 5 Brake pad wear sensor signal wheel 6 Service brake module Service brake module signal 1 (increasing) Service brake module signal 2 (decreasing) Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Page 134 of 276

SPN 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01072 01079 01079 01079 01079

Control unit/System EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c CNG_ME7 EDC7 HDS RET

SD 812a en-online 05.2007

Fault message Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Engine brake switch Supply voltage sensors 1 Supply to rail pressure sensor Tank sensor voltage supply Supply voltage pressure sensor 5 volts Page 135 of 276

SPN 01079 01080

Control unit/System VRET CNG_ME7

01080 01080 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086

EDC7 HDS AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R

SD 812a en-online 05.2007

Fault message Sensor voltage 5 volts Supply voltage sensors 2 Supply fuel supply pressure, charge air pressure and oil pressure sensor Pressure sensor electrical power supply Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Reservoir pressure circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Page 136 of 276

SPN 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01086 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087

Control unit/System PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12

SD 812a en-online 05.2007

Fault message Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Reservoir pressure circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 3 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Page 137 of 276

SPN 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01087 01088 01088 01088 01088 01088 01088 01088 01088 01088

Control unit/System EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS

SD 812a en-online 05.2007

Fault message Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Reservoir pressure circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Reservoir pressure circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 1 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Page 138 of 276

SPN 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088

Control unit/System EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR

SD 812a en-online 05.2007

Fault message Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Page 139 of 276

SPN 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01088 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089

Control unit/System TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD

SD 812a en-online 05.2007

Fault message Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 2 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Page 140 of 276

SPN 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01089 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090

Control unit/System INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6

SD 812a en-online 05.2007

Fault message Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 4 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Page 141 of 276

SPN 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090 01090

Control unit/System EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c

SD 812a en-online 05.2007

Fault message Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Pressure, pressure sensor - circuit 5 Page 142 of 276

SPN 01121 01131 01210 01213 01231 01231

Control unit/System VSM EDC7 EDC6 KSM EDC6 EDC7

01231 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235

FFR AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS

SD 812a en-online 05.2007

Fault message EBC1 message, 'Brake switch' signal Charge air temperature ahead of engine Rack Position Checklamp output Engine CAN Engine CAN The engine CAN sends the bus-off signal (MESSAGE TIMEOUT) J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 CAN short-circuit (BUSOFF) J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 Instrument CAN J 1939 Network #3 Page 143 of 276

SPN 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01235 01352 01353 01354 01355 01356 01357 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376

Control unit/System OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c CNG_ME7 CNG_ME7 CNG_ME7 CNG_ME7 CNG_ME7 CNG_ME7 AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6

SD 812a en-online 05.2007

Fault message J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 CAN SHORT CIRCUIT (BUSOFF) from CAN controller J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 J 1939 Network #3 Knock control cylinder 1 Knock control cylinder 2 Knock control cylinder 3 Knock control cylinder 4 Knock control cylinder 5 Knock control cylinder 6 Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Page 144 of 276

SPN 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376 01376

Control unit/System EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c

SD 812a en-online 05.2007

Fault message Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Tl. 30-1 connected Page 145 of 276

SPN 01485 01542 01623 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624

Control unit/System HDS HDS EMOS AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS

SD 812a en-online 05.2007

Fault message Main relay switched off Electrical power supply metering module Gearbox output speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Vehicle speed Road speed Road speed Road speed Road speed Page 146 of 276

SPN 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01624 01669 01673 01675 01676 01761 01981 02000 02000 02001 02001 02002 02003 02003 02004 02005 02006 02007 02008 02009 02009 02010 02011 02011 02012 02013 02014 02015 02015 02016 02016 02017 02018 02019 02020

Control unit/System RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c KSM ZBRO EMOS ZBR2 HDS VSM OBDU TBM OBDU TBM TBM OBDU TBM TBM TBM TBM TBM TBM OBDU TBM TBM OBDU TBM TBM TBM TBM OBDU TBM OBDU TBM TBM TBM TBM TBM

SD 812a en-online 05.2007

Fault message Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed Road speed A-CAN busoff Status body 3 CAN 'Engine start' signal No 'Break light request' signal in ERC_RX (timeout) AdBlue tank fill level Time overrun message ERC1_RMC EDC not on CAN No DM1 message from control unit 0 EDC slave not on CAN No DM1 message from control unit 1 No DM1 message from control unit 2 Gearbox not on CAN No DM1 message from control unit 3 No DM1 message from control unit 4 No DM1 message from control unit 5 No DM1 message from control unit 6 No DM1 message from control unit 7 No DM1 message from control unit 8 MAN Hydro Drive control unit not on CAN No DM1 message from control unit 9 No DM1 message from control unit 10 EBS not on CAN (pneumatic backup operation) No DM1 message from control unit 11 No DM1 message from control unit 12 No DM1 message from control unit 13 No DM1 message from control unit 14 Retarder engine not on CAN No DM1 message from control unit 15 Driveline retarder not on CAN No DM1 message from control unit 16 No DM1 message from control unit 17 No DM1 message from control unit 18 No DM1 message from control unit 19 No DM1 message from control unit 20 Page 147 of 276

SPN 02021 02022 02023 02023 02024 02025 02026 02027 02028 02029 02030 02031 02032 02033 02034 02035 02036 02037 02037 02038 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039

Control unit/System TBM TBM OBDU TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM OBDU TBM TBM AB ACC AST ASTMID BHTC CNG_ME7 CRT DIW5 EBS EBS_5 EBS_K1 ECAM ECAS_4X2 ECAS2_GBV ECAS2_GBW ECO2 EDC EDC_7 EDC_7_M EDC_7_MASTER EDC_7_S EDC_7_SLAVE EDC6 EDC64 EDC7 EDC7_6 EDC7C32 EDC7C32_6 EDC7C32_M EDC7C32_S EDC7C32M_10 EDC7C32M_12 EDC7C32S_10 EDC7C32S_12 EDC7M_10 EDC7M_12 EDC7S_10 EDC7S_12 EHLA EMOS

SD 812a en-online 05.2007

Fault message No DM1 message from control unit 21 No DM1 message from control unit 22 Instrumentation not on CAN No DM1 message from control unit 23 No DM1 message from control unit 24 No DM1 message from control unit 25 No DM1 message from control unit 26 No DM1 message from control unit 27 No DM1 message from control unit 28 No DM1 message from control unit 29 No DM1 message from control unit 30 No DM1 message from control unit 31 No DM1 message from control unit 32 No DM1 message from control unit 33 No DM1 message from control unit 34 No DM1 message from control unit 35 No DM1 message from control unit 36 Radio module not on CAN No DM1 message from control unit 37 No DM1 message from control unit 38 No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit FFR1: Timeout No text! Specific to control unit FFR1: Timeout No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit Page 148 of 276

SPN 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02039 02040 02041 02042 02042 02043 02044 02045 02046 02047 02047 02048 02048 02049 02049 02050 02051 02051

Control unit/System FFR GKR HDS HEITZ HVA HYD INST INT KR49X KSM LGS MTS OBDU OUZBRO OUZBRO_R PTM RAS RET SFFR SKG STON T509C TBM Test1Module Test2Module TPM TRON TRW TUER_DR TUER_PA UHV VRET VSM WSK ZBR2 ZBRO ZBRO_R ZFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c TBM TBM OBDU TBM TBM TBM TBM TBM OBDU TBM OBDU TBM OBDU TBM TBM OBDU TBM

SD 812a en-online 05.2007

Fault message No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit FFR not on CAN No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No DM1 message from control unit 39 No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No text! Specific to control unit No DM1 message from control unit 40 No DM1 message from control unit 41 ACC not on CAN No DM1 message from control unit 42 No DM1 message from control unit 43 No DM1 message from control unit 44 No DM1 message from control unit 45 No DM1 message from control unit 46 ECAS not on CAN No DM1 message from control unit 47 ECAM not on CAN No DM1 message from control unit 48 ZR-MUX not on CAN No DM1 message from control unit 49 No DM1 message from control unit 50 Tyre pressure control system (TPM) not on CAN No DM1 message from control unit 51 Page 149 of 276

SPN 02052 02053 02054 02055 02056 02056 02057 02058 02059 02060 02061 02061 02062 02062 02063 02064 02064 02065 02066 02067 02067 02068 02069 02070 02071 02072 02073 02074 02075 02076 02077 02078 02079 02080 02081 02082 02083 02084 02085 02086 02087 02088 02089 02090 02091 02092 02093 02094 02095 02096 02097 02098 02099 02100 02101 02102 02103 02104 02105 02106

Control unit/System TBM TBM TBM TBM OBDU TBM TBM TBM TBM TBM OBDU TBM OBDU TBM TBM OBDU TBM TBM TBM OBDU TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM

SD 812a en-online 05.2007

Fault message No DM1 message from control unit 52 No DM1 message from control unit 53 No DM1 message from control unit 54 No DM1 message from control unit 55 Control unit of the steering rear axle (RAS) not on CAN No DM1 message from control unit 56 No DM1 message from control unit 57 No DM1 message from control unit 58 No DM1 message from control unit 59 No DM1 message from control unit 60 Control unit of the exhaust post-treatment not on CAN No DM1 message from control unit 61 ESP not on CAN No DM1 message from control unit 62 No DM1 message from control unit 63 ECAS 2 not on CAN No DM1 message from control unit 64 No DM1 message from control unit 65 No DM1 message from control unit 66 Torque converter and clutch system (WSK) not on CAN No DM1 message from control unit 67 No DM1 message from control unit 68 No DM1 message from control unit 69 No DM1 message from control unit 70 No DM1 message from control unit 71 No DM1 message from control unit 72 No DM1 message from control unit 73 No DM1 message from control unit 74 No DM1 message from control unit 75 No DM1 message from control unit 76 No DM1 message from control unit 77 No DM1 message from control unit 78 No DM1 message from control unit 79 No DM1 message from control unit 80 No DM1 message from control unit 81 No DM1 message from control unit 82 No DM1 message from control unit 83 No DM1 message from control unit 84 No DM1 message from control unit 85 No DM1 message from control unit 86 No DM1 message from control unit 87 No DM1 message from control unit 88 No DM1 message from control unit 89 No DM1 message from control unit 90 No DM1 message from control unit 91 No DM1 message from control unit 92 No DM1 message from control unit 93 No DM1 message from control unit 94 No DM1 message from control unit 95 No DM1 message from control unit 96 No DM1 message from control unit 97 No DM1 message from control unit 98 No DM1 message from control unit 99 No DM1 message from control unit 100 No DM1 message from control unit 101 No DM1 message from control unit 102 No DM1 message from control unit 103 No DM1 message from control unit 104 No DM1 message from control unit 105 No DM1 message from control unit 106 Page 150 of 276

SPN 02107 02108 02109 02110 02111 02112 02113 02114 02114 02115 02116 02117 02118 02119 02120 02120 02121 02122 02123 02123 02124 02125 02126 02127 02128 02129 02130 02131 02132 02133 02134 02135 02136 02137 02138 02139 02140 02141 02142 02143 02144 02145 02146 02147 02148 02149 02150 02151 02152 02153 02154 02155 02156 02157 02158 02159 02160 02161 02162 02163

Control unit/System TBM TBM TBM TBM TBM TBM TBM OBDU TBM TBM TBM TBM TBM TBM OBDU TBM TBM TBM OBDU TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM

SD 812a en-online 05.2007

Fault message No DM1 message from control unit 107 No DM1 message from control unit 108 No DM1 message from control unit 109 No DM1 message from control unit 110 No DM1 message from control unit 111 No DM1 message from control unit 112 No DM1 message from control unit 113 VSM not on CAN No DM1 message from control unit 114 No DM1 message from control unit 115 No DM1 message from control unit 116 No DM1 message from control unit 117 No DM1 message from control unit 118 No DM1 message from control unit 119 ZFR not on CAN No DM1 message from control unit 120 No DM1 message from control unit 121 No DM1 message from control unit 122 CRT not on CAN No DM1 message from control unit 123 No DM1 message from control unit 124 No DM1 message from control unit 125 No DM1 message from control unit 126 No DM1 message from control unit 127 No DM1 message from control unit 128 No DM1 message from control unit 129 No DM1 message from control unit 130 No DM1 message from control unit 131 No DM1 message from control unit 132 No DM1 message from control unit 133 No DM1 message from control unit 134 No DM1 message from control unit 135 No DM1 message from control unit 136 No DM1 message from control unit 137 No DM1 message from control unit 138 No DM1 message from control unit 139 No DM1 message from control unit 140 No DM1 message from control unit 141 No DM1 message from control unit 142 No DM1 message from control unit 143 No DM1 message from control unit 144 No DM1 message from control unit 145 No DM1 message from control unit 146 No DM1 message from control unit 147 No DM1 message from control unit 148 No DM1 message from control unit 149 No DM1 message from control unit 150 No DM1 message from control unit 151 No DM1 message from control unit 152 No DM1 message from control unit 153 No DM1 message from control unit 154 No DM1 message from control unit 155 No DM1 message from control unit 156 No DM1 message from control unit 157 No DM1 message from control unit 158 No DM1 message from control unit 159 No DM1 message from control unit 160 No DM1 message from control unit 161 No DM1 message from control unit 162 No DM1 message from control unit 163 Page 151 of 276

SPN 02164 02165 02166 02167 02168 02169 02170 02171 02172 02173 02174 02175 02176 02177 02178 02179 02180 02181 02182 02183 02184 02185 02186 02187 02188 02189 02190 02191 02192 02193 02194 02195 02196 02197 02198 02199 02200 02201 02202 02203 02204 02205 02206 02207 02208 02209 02210 02211 02212 02213 02214 02215 02216 02217 02218 02219 02220 02221 02222 02223

Control unit/System TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM

SD 812a en-online 05.2007

Fault message No DM1 message from control unit 164 No DM1 message from control unit 165 No DM1 message from control unit 166 No DM1 message from control unit 167 No DM1 message from control unit 168 No DM1 message from control unit 169 No DM1 message from control unit 170 No DM1 message from control unit 171 No DM1 message from control unit 172 No DM1 message from control unit 173 No DM1 message from control unit 174 No DM1 message from control unit 175 No DM1 message from control unit 176 No DM1 message from control unit 177 No DM1 message from control unit 178 No DM1 message from control unit 179 No DM1 message from control unit 180 No DM1 message from control unit 181 No DM1 message from control unit 182 No DM1 message from control unit 183 No DM1 message from control unit 184 No DM1 message from control unit 185 No DM1 message from control unit 186 No DM1 message from control unit 187 No DM1 message from control unit 188 No DM1 message from control unit 189 No DM1 message from control unit 190 No DM1 message from control unit 191 No DM1 message from control unit 192 No DM1 message from control unit 193 No DM1 message from control unit 194 No DM1 message from control unit 195 No DM1 message from control unit 196 No DM1 message from control unit 197 No DM1 message from control unit 198 No DM1 message from control unit 199 No DM1 message from control unit 200 No DM1 message from control unit 201 No DM1 message from control unit 202 No DM1 message from control unit 203 No DM1 message from control unit 204 No DM1 message from control unit 205 No DM1 message from control unit 206 No DM1 message from control unit 207 No DM1 message from control unit 208 No DM1 message from control unit 209 No DM1 message from control unit 210 No DM1 message from control unit 211 No DM1 message from control unit 212 No DM1 message from control unit 213 No DM1 message from control unit 214 No DM1 message from control unit 215 No DM1 message from control unit 216 No DM1 message from control unit 217 No DM1 message from control unit 218 No DM1 message from control unit 219 No DM1 message from control unit 220 No DM1 message from control unit 221 No DM1 message from control unit 222 No DM1 message from control unit 223 Page 152 of 276

SPN 02224 02225 02226 02227 02228 02229 02230 02231 02232 02232 02233 02234 02235 02236 02237 02238 02238 02239 02240 02241 02242 02243 02244 02245 02246 02247 02248 02249 02250 02251 02251 02252 02253 02253 02254 02255

Control unit/System TBM TBM TBM TBM TBM TBM TBM TBM OBDU TBM TBM TBM TBM TBM TBM OBDU TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM TBM OBDU TBM TBM OBDU TBM TBM TBM

02987

INST

02987

STON

02987 02999 02999 02999 02999 03000 03000 03000

ZBR2 DIW5 ECO2 RET VRET BHTC EBS EHLA

03000 03000 03000 03000 03000 03000 03001 03001

KSM SKG TBM TPM TRW ZBR2 ACC BHTC

03001

EBS

SD 812a en-online 05.2007

Fault message No DM1 message from control unit 224 No DM1 message from control unit 225 No DM1 message from control unit 226 No DM1 message from control unit 227 No DM1 message from control unit 228 No DM1 message from control unit 229 No DM1 message from control unit 230 No DM1 message from control unit 231 Lane guard system not on CAN No DM1 message from control unit 232 No DM1 message from control unit 233 No DM1 message from control unit 234 No DM1 message from control unit 235 No DM1 message from control unit 236 No DM1 message from control unit 237 Tachograph not on CAN No DM1 message from control unit 238 No DM1 message from control unit 239 No DM1 message from control unit 240 No DM1 message from control unit 241 No DM1 message from control unit 242 No DM1 message from control unit 243 No DM1 message from control unit 244 No DM1 message from control unit 245 No DM1 message from control unit 246 No DM1 message from control unit 247 No DM1 message from control unit 248 No DM1 message from control unit 249 No DM1 message from control unit 250 Telematic onboard module not on CAN No DM1 message from control unit 251 No DM1 message from control unit 252 KSM not on CAN No DM1 message from control unit 253 No DM1 message from control unit 254 No DM1 message from control unit 255 Parameter set in combination gauge or chassis number in tachograph not adapted to the vehicle Parameter set in instrument cluster or in tachograph not adapted Parameter record in central on-board computer 2 or chassis number in tachograph not adapted to vehicle Retarder function Retarder reduction if a temperature threshold is exceeded Power limit (temperature adaptation) Power limit (temperature adaptation) Outside temperature sensor No fault Electronics error function computer CAN data bus: Time overrun when receiving VMC message ETC1. Temperature at outfeed of evaporator (KTT n. KTBV) An unexpected RESET has occurred Tyre pressure EEPROM checksums are not correct ZBR system Additional information 1 Evaporator temperature sensor Control unit defective; unknown µC interrupt, µC self-test, RAM or ROM test Page 153 of 276

SPN

Control unit/System

03001 03001 03001 03001 03001 03001 03001 03001 03001

EBS_K1 ECAS_4X2 ECAS2_GBV EDC6 EDC7 EHLA FFR GKR KR49X

03001 03001 03001 03001 03001 03001 03001 03001 03001 03001 03002 03002 03002

KSM RET SFFR SKG TBM TRW TUER_DR VRET ZBR2 ZBRO ACC AST BHTC

03002 03002 03002 03002 03002 03002

EBS EDC6 EDC7 EHLA GKR KR49X

03002 03002 03002 03002 03002 03002 03002 03002 03003 03003 03003 03003 03003 03003 03003 03003

KSM RET SFFR TBM TRW TUER_DR VRET ZBRO ACC AST BHTC EBS EDC6 EDC7 GKR KR49X

03003 03003 03003 03003 03003 03003 03003 03003 03003 03004 03004

KSM RET SFFR SKG TBM TRW TUER_DR VRET ZBRO ACC AST

SD 812a en-online 05.2007

Fault message Control unit defects; unknown µC interrupt, self-test, RAM or ROM test Control unit (internal fault) Control unit (internal fault) Engine speed sensor, reverse polarity Engine speed sensor, reverse polarity Electronic error safety computer Term. 30, continuous positive Interior air temperature sensor External sensor CAN data bus: Time overrun when receiving VMC message ETC2. Temperature sensor before engine (T1) Driver's request Temperature at outfeed of ice accumulator (KTT n ESP) Real-time clock TBM RHD/LHD parameter setting is not correct RESET Temperature sensor T1 (water) Wake up, computer External wake-up ZR Additional information 2 Y2 valve splitter low Heat exchanger temperature sensor Control unit defective, timeout in data exchange µC active – µC passive Segment speed Segment speed Digital output parameters External air temperature sensor Space sensor CAN data bus: Time overrun when receiving VMC message ETC3. Temperature sensor after engine (T2) Speed request ship vehicle management computer Fault in EEPROM Undervoltage (TL31 < 16V) EE_CHECKSUM_ERROR Temperature sensor T2 (oil) External wake-up1 ZR Additional information 3 Y3 valve splitter high Interior temperature sensor Control unit defective; redundancy fault µc input signal Engine speed sensor/auxiliary speed sensor swapped over Engine speed sensor/auxiliary speed sensor swapped over Blow-out air temperature sensor Roof duct sensor CAN data bus: Time overrun when receiving EBS message EBC1. Fault (watchdog drop-out / internal error in control unit) Terminal 15 Motor / valve B Fault in RAM disk Overvoltage (TL30 > 32V) SIDE_INFORMATION_ERROR Fault (watchdog drop-out / internal error in control unit) External wake-up2 ZR Additional information 4 Y4 valve gate position 3 / 4 Page 154 of 276

SPN 03004

Control unit/System BHTC

03004 03004 03004 03004 03004

EBS EDC6 EDC7 GKR KR49X

03004 03004 03004 03004 03004 03004 03004 03004 03004 03005 03005 03005 03005 03005 03005 03005 03005

KSM LGS RET SFFR SKG TBM TUER_DR VRET ZBRO AST EBS EBS_K1 EDC6 EDC7 EHLA GKR KR49X

03005 03005 03005 03005 03005 03005 03005 03005 03005 03006 03006 03006 03006 03006 03006

KSM RET SFFR SKG TBM TRW TUER_DR VRET ZBRO AST EBS EDC6 EDC7 GKR KR49X

03006 03006 03006 03006 03006 03006 03006 03007 03007 03007 03007 03007 03007

KSM RET SKG TRW TUER_DR VRET ZBRO AST EBS EDC6 EDC7 GKR KR49X

03007 03007 03007 03007

KSM RET SKG TRW

SD 812a en-online 05.2007

Fault message Contact sensor low-temperature accumulator Control unit defective, checksum data exchange µC active – µC passive EGR valve position AGR residual control deviation Bypass flap motor potentiometer Convector sensor CAN data bus: Time overrun when receiving EDC message CcVeh_speed. Control unit EEPROM (data record fault) Voltage selector lever Motor / valve C Operating temperature TBM ILLEGAL_STATE EEPROM (data record fault) External wake-up ZR by IKN Y5 valve gate position 1 / 2 Control unit defective; EEPROM fault: Checksum not correct EEPROM error, parameter setting Timeout, message location 13 Timeout, message location 13 Proportional valve outputs Heating valve Front box sensor CAN data bus: Time overrun when receiving EDC message EEC1. ROM (checksum incorrect) Voltage pedal value sensor Main pump Overcurrent at digital power current outputs The co-driver's door module has not responded to the LIN ILLEGAL_EVENT ROM (checksum incorrect) Status ZR fault number Y6 valve shift position 1 / R No valid fault definition Primary speed Primary speed Recirculation ventilation flap motor Icing sensor CAN data bus: Time overrun when receiving EDC message EEC2. CAN data bus, TSC1 - message Recirculating pump A reset was performed in the door module due to a fault Window lifter motor CAN data bus, TSC1 - message K3-CAN activation Y3 valve shift position 2 / 3 No valid fault definition DM4 request, invalid PGN DM4 request, invalid PGN Bypass flap motor Water sensor CAN data bus: Time overrun when receiving EDC message Eng_Temp. CAN data bus, EEC1 - message Communication control element – control unit Driver's door central locking fault (open / close) Page 155 of 276

SPN 03007 03007 03008 03008 03008 03008 03008 03008 03008

Control unit/System TUER_DR ZBRO AST EBS EDC6 EDC7 EHLA GKR KR49X

03008 03008 03008 03008 03008 03008 03008 03009 03009 03009 03009 03009 03009

KSM RET SKG TRW TUER_DR VRET ZBRO AST EBS EDC6 EDC7 EHLA KR49X

03009 03009 03009 03009 03009 03009 03010 03010

KSM RET SKG TUER_DR VRET ZBRO AST BHTC

03010 03010 03010 03010 03010 03010 03010 03010 03010

EBS EBS_K1 ECAS_4X2 ECAS2_GBV EDC6 EDC7 EHLA FFR KR49X

03010 03010 03010 03010 03010

KSM LGS RET SKG TBM

03010 03010 03010 03011 03011

TPM TUER_DR VRET BHTC CNG_ME7

03011 03011 03011 03011 03011

EBS ECAS_4X2 ECAS2_GBV EDC6 EDC7

SD 812a en-online 05.2007

Fault message right/left switch (mirrors) T-CAN activation Y3 valve range-change group low Control unit defective; test transfer from µc to CAN trailer IC FFR3: Retarder oil temperature invalid FFR3: Retarder oil temperature invalid Sensor supply, deviation Blower control voltage Compressor CAN data bus: Time overrun when receiving EDC message EngFlui_LevPre. CAN data bus, TCO1 - message Filling/bleeding mode not completed correctly Co-driver's door central locking fault (open / close) Window lifter shut-off CAN data bus, TC01 - message Central computer running on Y3 valve range-change group high Control unit defective; redundancy fault µc output signal Overspeed Overspeed Voltage supply switched on when vehicle moving Auxiliary heater CAN data bus: Time overrun when receiving EDC message Amb_Cond. CAN data bus, ERC1 - message Controller mode Mirror adjust time exceeded CAN data bus, ERC1 - message Multiplex error Y10 main valve Contact sensor evaporator Control unit defective; wheel diameter compensation value not correct (!) Wheel diameter: Compensation value not correct Control unit (checksum ECU-specific data) Control unit (checksum ECU-specific data) Control deviation, injection start Control deviation, injection start Signature EOL parameter advance warning Torque and engine speed limiting system Roof duct valve CAN data bus: Time overrun when receiving ECAM message ECAM1. Turn indicator signal CAN data bus, start error monitoring On-board voltage (terminal 30) No GPS signal Slight leakage: Slight pressure loss at min. one tyre > approx. 20 mbar/h incorrect CAN command, door lock CAN data bus, start error monitoring Stepper motor side nozzle Heating probe before catalytic converter (output stage) Control unit defective; error in service brake valve characteristic Control unit (checksum parameter) Control unit (checksum parameter) Angle of injection start Angle of injection start Page 156 of 276

SPN 03011 03011 03011

Control unit/System EHLA FFR KR49X

03011 03011 03011 03011 03011 03012

KSM LGS TBM TPM TUER_DR BHTC

03012 03012 03012 03012 03012 03012 03012 03012

EBS EBS_K1 ECAS_4X2 ECAS2_GBV EDC6 EDC7 EHLA KR49X

03012 03012 03012 03012 03013

KSM LGS RET TPM BHTC

03013 03013 03013 03013 03013 03013 03013

EBS ECAS_4X2 ECAS2_GBV EDC6 EDC7 EHLA KR49X

03013 03013 03013 03013 03014 03014 03014 03014 03014 03014 03014 03014 03014 03014 03014 03014 03015 03015 03015 03015 03015 03015 03015 03015 03015 03015

KSM RET TPM VRET BHTC EBS EBS_K1 EDC6 EDC7 EHLA KR49X KSM LGS RET TPM VRET BHTC EBS EBS_K1 ECAS_4X2 ECAS2_GBV EDC6 EDC7 EHLA KR49X KSM

SD 812a en-online 05.2007

Fault message Signature EOL parameter EVB pressure sensor Valve driver heating/cooling CAN data bus: Time overrun when receiving CBR message Aux_Stat_Zbr1. Left loudspeaker GPS aerial current Pressure in left outer tyre, axle 1 Central locking does not lock Stepper motor recirculated air Control unit defective; incompatibility in data record version number EEPROM parameters Control unit (checksum calibration data travel sensors) Control unit (checksum calibration data travel sensors) CAN module CAN module Value range EOL parameter Valve convector CAN data bus: Time overrun when receiving CBR message Time_Date. Right loudspeaker Pressure from cooler valve (brake lamp) Pressure in left inner tyre, axle 1 Stepper motor air distribution Control unit defective; characteristic in EEPROM not plausible Control unit (checksum calibration data pressure sensors) Control unit (checksum calibration data pressure sensors) CAN bus off CAN bus off Steering pressure sensor Central valve CAN data bus: Time overrun when receiving CBR message Veh_Dist. Axial thrust (outside tolerance) Pressure in right inner tyre, axle 1 Axial thrust (outside tolerance) Stepper motor bypass No valid fault definition Control unit electrical power supply (tl. 30a) Main relay blocked Main relay blocked Pressure supply Valve driver heating CAN data bus: Time overrun when receiving C34. Camera module too hot Pressure sensor positioning pressure Pressure in right outer tyre, axle 1 Pressure sensor positioning pressure Stepper motor valve B No valid fault definition Control unit electrical power supply (tl. 30b) Control unit (checksum permitted axle loads) Control unit (checksum permitted axle loads) max. time after TERM. 15 OFF exceeded max. time after TERM. 15 OFF exceeded Pressure supply warning Front box window flap Control unit (RAM) Page 157 of 276

SPN 03015 03015 03016 03016

Control unit/System LGS TBM EBS EBS_K1

03016

ECAS_4X2

03016 03016 03016 03016 03016 03016 03017 03017 03017 03017 03017 03017 03017 03018 03018 03018 03018 03018 03018 03018 03018 03019 03019 03019 03019 03019 03019 03019

ECAS2_GBV EDC6 EDC7 KR49X KSM LGS AST EBS EBS_K1 EDC6 EDC7 KR49X KSM AST EBS EBS_K1 EDC6 EDC7 EHLA KR49X KSM AST EBS EBS_K1 EDC6 EDC7 EHLA KR49X

03019 03020 03020 03020 03020 03020 03020 03020 03020 03020

KSM AST EBS EDC6 EDC7 FFR KR49X KSM SFFR TBM

03020 03021 03021 03021

TPM AST EBS EBS_K1

03021

EDC6

03021 03021 03021 03021

EDC7 EHLA FFR KR49X

03021

KSM

SD 812a en-online 05.2007

Fault message Output driver's seat vibration left GSM modem No valid fault definition Control unit electrical power supply (tl. 15) Control unit (checksum calibration data acceleration sensors) Control unit (checksum calibration data acceleration sensors) FFR1: Bit error zero quantity due to engine brake FFR1: Bit error zero quantity due to engine brake Front box foot flap Control unit (ROM) Output driver's seat vibration right Y1 clutch brake No valid fault definition ECU supply (external supply) FFR1: Bit error nominal torque FFR1: Bit error nominal torque Fresh air flap left Control unit (watchdog) Small valve for opening the clutch No valid fault definition (!) Braking level selector lever 1 or 2 FFR1: Bit error top-speed governor parameter ID FFR1: Bit error top-speed governor parameter ID Oil level in tank Fresh air flap right Control unit (EEPROM parameter) Small valve for closing the clutch No valid fault definition (!) Setpoint sensing (accelerator to brake pedal position) FFR1: EDR min. nominal value not reached FFR1: EDR min. nominal value not reached Oil filter blocked Front box blower Control unit (internal relay voltage supply or short-circuit terminal 30 - terminal 30 switched output Large valve for opening the clutch Faulty supply voltage (5 volts) for analog sensors FFR1: Bit error, EDR nominal value FFR1: Bit error, EDR nominal value Accelerator pedal, PWM1 signal Evaporator blower left Control unit (EEPROM fault memory) Supply voltage Breakdown switch Medium leakage: Pressure loss at min. one tyre approx. 80 mbar/h Large valve for closing the clutch Faulty pedal brake module potentiometer signal Pedal brake module - setpoint signal 1 or 2 FFR1: Bit error intermediate speed governing system parameter ID FFR1: Bit error intermediate speed governing system parameter ID CAN message 'EEC1' Accelerator pedal, PWM2 signal Condenser blower left CAN data bus: Time overrun when receiving vehicle management computer message Fuel_Cons. Page 158 of 276

SPN 03021 03021 03021 03022 03022 03022 03022 03022 03022

Control unit/System SFFR TBM TPM AST EBS EDC6 EDC7 FFR KR49X

03022 03022 03022 03022 03023 03023 03023 03023

KSM SFFR TBM TPM EBS EDC6 EDC7 KR49X

03023 03023 03023 03023 03024 03024 03024 03024 03024 03024 03024

KSM SFFR TBM TPM AST EBS EBS_K1 EDC6 EDC7 EHLA KR49X

03024 03024 03024 03024

KSM SFFR TBM TPM

03025 03025 03025 03025 03025 03025

EBS EBS_K1 EDC6 EDC7 EHLA KR49X

03025 03025 03025

KSM SFFR TBM

03026 03026

AST CNG_ME7

03026 03026 03026 03026 03026 03026 03026

EBS EBS_K1 EDC6 EDC7 EHLA EMOS KR49X

03026 03026

KSM SFFR

SD 812a en-online 05.2007

Fault message Pedal value sensor Alarm switch Pressure in left outer tyre, axle 2 Electrical power supply, speed sensor ASTronic output Faulty axle load sensor 1 FFR1: ISG nominal value FFR1: ISG nominal value Accelerator pedal, PWM1 and PWM2 signal Evaporator blower right CAN data bus: Time overrun when receiving central on-board computer message Dash_Disp. Selector lever Chassis number Pressure in left inner tyre, axle 2 Faulty axle load sensor 2 FFR1: Bit error request torque overrevving FFR1: Bit error request torque overrevving Condenser blower right CAN data bus: Time overrun when receiving EBS/ECAS message Veh_Weight. Idling speed harmonisation Geographic width Pressure in right inner tyre, axle 2 Current WSK retarder torque in percent Brake pad wear: Incorrect tendency between the axles Dynamic pad trend fault axles FFR1: Bit error, request ramps off/out FFR1: Bit error, request ramps off/out Engine revs Water station U2 CAN data bus: Time overrun when receiving vehicle management computer message Eng_Hour/Rev. Default driving unit Geographic length Pressure in right outer tyre, axle 2 Brake pad wear: Incorrect tendency between the wheels of axle 1 Dynamic pad trend fault front axles FFR1: reserved Bits & Bytes FFR1: reserved Bits & Bytes Cab position, impermissible change when vehicle moving CAN node U3 CAN data bus: Time overrun when receiving tachograph message Veh_Ident. Engine CAN GPS position data CAN data bus engine configuration from the EDC, engine configuration Vehicle management computer message 1 Brake pad wear: Incorrect tendency between the wheels of axle 2 Dynamic pad trend fault rear axle 1 FFR1: Timeout FFR1: Timeout Cab position, vehicle moving when swivelling Timeout of Engine_Config message CAN node U4 CAN data bus: Time overrun when receiving vehicle management computer message Service. MMDS CAN Page 159 of 276

SPN 03026

Control unit/System TBM

03027

AST

03027 03027 03027 03027 03027 03027

EBS EBS_K1 EDC6 EDC7 EHLA KR49X

03027

KSM

03027

SFFR

03028

AST

03028 03028 03028 03028 03028

EBS EBS_K1 EDC6 EDC7 EHLA

03028

KSM

Engine CAN: Time overrun when receiving EDC message EDC1 CAN data bus retarder check from secondary retarder, ERC1_RD (current retarder torque) Brake pad wear: Incorrect tendency between the wheels of axle 4 Dynamic pad trend fault additional axle FFR2: Nominal torque value too low FFR2: Nominal torque value too low Cab position, swivelling is taking too long CAN data bus: Time overrun when receiving vehicle management computer message ERC1_RX.

03028

SFFR

Engine CAN: Time overrun when receiving EDC message EDC2

03029 03029 03029 03029 03029 03029 03029

AST EBS EBS_K1 EDC6 EDC7 EHLA EMOS

03029

KSM

03029

SFFR

03030 03030

AST BHTC

03030 03030 03030 03030

EBS EDC6 EDC7 EHLA

03030

KSM

03030

SFFR

03030

TPM

03031 03031 03031 03031 03031

AST EBS EDC6 EDC7 EHLA

SD 812a en-online 05.2007

Fault message CPU TRAP register CAN data bus engine configuration from the EDC, engine configuration Brake pad wear: Incorrect tendency between the wheels of axle 3 Dynamic pad trend fault rear axle 2 FFR2: Driveline fault FFR2: Driveline fault Cab position CAN bus several nodes missing CAN data bus: Time overrun when receiving tachograph message TCO1.

CAN data bus retarder check from secondary retarder, ERC1 (additional heating of the engine, engine coolant load increase) No valid fault definition SPN undefined FFR2: Bit error, nominal idling value FFR2: Bit error, nominal idling value Emergency steering pump, no oil volume 'Request engine speed increase in braking mode' signal CAN data bus: Time overrun when receiving tachograph message BAM_MTCO_VIN. Engine CAN: Time overrun when receiving EDC message EDC3 CAN data bus retarder configuration from secondary retarder, Ret_Conf driveline retarder configuration Stepper motor valve C Faulty brake pad wear and retarder relay output stage checkback FFR2: Bit error, idling speed governing parameter ID FFR2: Bit error, idling speed governing parameter ID Emergency steering pump CAN data bus: Time overrun when receiving tachograph message P_MTCO_VIN. Engine CAN: Time overrun when receiving EDC message EDC4 Severe leakage: Severe pressure loss at min. one tyre approx. 200 mbar/h CAN data bus retarder check from vehicle management computer engine brake torque 'ERC1_ REX retarder percent torque' Faulty retarder relay output stage checkback FFR2: nominal idling speed governing value too high FFR2: nominal idling speed governing value too high Pressure build-up in pressure accumulator too short Page 160 of 276

SPN 03031

Control unit/System HDS

03031

KSM

03031 03031

SFFR TPM

03032 03032 03032 03032 03032

AST EBS EDC6 EDC7 EHLA

03032

KSM

03032 03032

SFFR TPM

03033 03033 03033 03033 03033

AST EBS EDC6 EDC7 EHLA

03033

KSM

03033 03033 03034 03034 03034

SFFR TPM EBS EDC6 EDC7

03034 03034

EHLA KSM

03034 03034 03035 03035 03035 03035 03035

SFFR TPM EBS EBS_K1 EDC6 EDC7 EHLA

03035

KSM

03035 03036 03036 03036 03036

SFFR CNG_ME7 EBS EDC6 EDC7

03036 03037

KSM EBS

03037 03037 03037

EBS_K1 EDC6 EDC7

03037 03038

KSM EBS

SD 812a en-online 05.2007

Fault message AdBlue tank temperature Adjustment lever angle reduction input (throttle butterfly reduction request) Engine CAN: Time overrun when receiving EDC message EDC5 Pressure in left outer tyre, axle 3 CAN data bus engine brake configuration, 'engine retarder configuration' Faulty brake pad wear output stage checkback FFR2: Bit error, stand alone request FFR2: Bit error, stand alone request Centring circuit warning Signal frequency at adjustment lever angle reduction input (throttle butterfly reduction request) Engine CAN: Time overrun when receiving EDC message EngineConfig Pressure in left inner tyre, axle 3 CAN data bus engine brake configuration, 'engine retarder configuration' Invalid checkback signal for the yellow warning light FFR2: Bit error, start request FFR2: Bit error, start request Centring circuit CAN data bus: Time overrun when receiving body CAN message KSM2_A. MMDS CAN: Time overrun when receiving MMDS message TSC1-FME. Pressure in right inner tyre, axle 3 Invalid checkback signal for the red warning light FFR2: Bit error, engine stop request FFR2: Bit error, engine stop request Actuator test of axle behaviour in centring circuit, implausible Power take-off output MMDS CAN: Time overrun when receiving MMDS message Time/Date Pressure in right outer tyre, axle 3 No valid fault definition Electrical power supply axle modulator FFR2: reserved Bits & Bytes FFR2: reserved Bits & Bytes Actuator test of pressure behaviour in centring circuit CAN data bus: Time overrun when receiving retarder message EBC3. MMDS CAN: Time overrun when receiving MMDS message VehDistance Vehicle management computer message 2 Short-circuit on one of the module output stages FFR2: Timeout FFR2: Timeout CAN data bus: Time overrun when receiving retarder message ERC1_RE. No valid fault definition Vehicle dynamics control steering angle sensor electrical power supply FFR3: Bit error, pedal value sensor position FFR3: Bit error, pedal value sensor position CAN data bus: Time overrun when receiving user-definable message FREI_1. No valid fault definition Page 161 of 276

SPN 03038 03038 03038

Control unit/System EBS_K1 EDC6 EDC7

03038 03039 03039 03039 03039

KSM EBS EBS_K1 EDC6 EDC7

03039 03040 03040 03040 03040 03040 03040 03040

KSM BHTC CNG_ME7 EBS EBS_K1 EDC6 EDC7 EHLA

03040 03041

KSM BHTC

03041 03041 03041 03041 03041

EBS EDC6 EDC7 EHLA TPM

03042 03042 03042

EBS EDC6 EHLA

03042 03042

KSM TPM

03043 03043 03043 03043 03043 03044

EBS EDC6 EDC7 EHLA TPM CNG_ME7

03044 03044 03044 03045

EBS EHLA TPM CNG_ME7

03045 03045 03045 03045

EBS EDC6 EDC7 EHLA

03046 03046 03046 03046

EBS EDC6 EDC7 EHLA

03047 03047 03047

EBS EDC6 EDC7

SD 812a en-online 05.2007

Fault message Interaxle lock FFR3: Bit error, standstill info. FFR3: Bit error, standstill info. CAN data bus: Time overrun when receiving user-definable message FREI_2. No valid fault definition Lock relay, front axle FFR3: reserved Bits & Bytes FFR3: reserved Bits & Bytes CAN data bus: Time overrun when receiving user-definable message FREI_3. Blower Vehicle management computer message 3 No valid fault definition Display bus-stop brake FFR3: Timeout FFR3: Timeout Angle encoder configuration CAN data bus: Time overrun when receiving user-definable message FREI_4. Compressor Engine interface, adjustment lever angle increase input, permanently low, > 400 ms DM4 request frequency too high ( docu. page 172 ) DM4 request frequency too high ( docu. page 172 ) Angle encoder supply Pressure in left outer tyre, axle 4 Engine interface, adjustment lever angle increase input, permanently high, > 400 ms FFR2: Input shaft speed invalid Angle encoder, steering axle 1, differential CAN data bus: Time overrun when receiving FFR (vehicle management computer) message Fuel_Eco. Pressure in left inner tyre, axle 4 Engine interface, adjustment lever angle increase input, frequency > 220 Hz Fault memory info., timeout, message location 10 Fault memory info., timeout, message location 10 Angle encoder, steering axle 1, total voltage Pressure in right inner tyre, axle 4 Lambda control adaptation additive (bank 1) Engine interface, adjustment lever angle increase input, mark-tospace ratio > 95 % Angle encoder, steering axle 1 Pressure in right outer tyre, axle 4 Starter control: Blocked Engine interface, adjustment lever angle increase input, mark-tospace ratio < 5 % Starter activation defective Starter activation defective Angle encoder, steering axle 1, track 1 Engine interface, adjustment lever angle increase input, mark-tospace ratio > 95 % Atmospheric pressure detection Atmospheric pressure detection Angle encoder, steering axle 1, track 2 Engine interface, adjustment lever angle increase input, permanently low or high 80 – 400 ms Overrun test gate array monitoring module Overrun test gate array monitoring module Page 162 of 276

SPN 03047 03048 03048 03048 03048 03049 03049 03049 03049 03049 03049 03050 03050 03050 03050 03050 03050 03050 03050 03050 03051 03051

Control unit/System EHLA EBS EDC6 EDC7 EHLA AST EBS EBS_K1 EDC6 EDC7 EHLA AST BHTC EBS EBS_K1 ECAS_4X2 ECAS2_GBV EDC6 EDC7 EHLA AST BHTC

03051

EBS

03051

EBS_5

03051 03051 03051 03051 03051 03051 03051 03052 03052

EBS_K1 ECAS_4X2 ECAS2_GBV EDC6 EDC7 EHLA TPM AST EBS

03052 03052 03052 03052 03052 03052 03052 03053 03053 03053 03053 03053 03053 03053 03053 03053 03054 03054 03054 03054 03054 03054

EBS_K1 ECAS_4X2 ECAS2_GBV EDC6 EDC7 EHLA TPM AST EBS EBS_K1 ECAS_4X2 ECAS2_GBV EDC6 EDC7 EHLA TPM EBS ECAS_4X2 ECAS2_GBV EDC6 EDC7 EHLA

SD 812a en-online 05.2007

Fault message Angle encoder, steering axle 2, differential No valid fault definition Overrun test undervoltage monitoring Overrun test undervoltage monitoring Angle encoder, steering axle 2, total voltage Y1 clutch brake CAN data bus driveline, receive time exceeded CAN data bus driveline, receive time exceeded Overrun test overvoltage monitoring Overrun test overvoltage monitoring Angle encoder, steering axle 2 Small valve for opening the clutch Solenoid valve CAN data bus driveline, bus off CAN data bus driveline, bus off Control unit, supply voltage Control unit, supply voltage After-run test, zero quantity After-run test, zero quantity Angle encoder, steering axle 2, track 1 Small valve for closing the clutch Terminal 30 voltage CAN data bus driveline, receive time exceeded in EEC1 message from the EDC J1939 driveline CAN: Time overrun or fault condition in communication with vehicle management computer control unit CAN J 1939 receive time exceeded in message EEC1 from the EDC Operator unit data Operator unit data After-run test, MES1 output After-run test, MES1 output Angle encoder, steering axle 2, track 2 Pressure in left outer tyre, axle 5 Large valve for opening the clutch No valid fault definition CAN J 1939 receive time exceeded in message EEC2 from the EDC Operator unit clock Operator unit clock Timeout, message location 5 Timeout, message location 5 Angle encoder, steering axle 3, differential Pressure in left inner tyre, axle 5 Large valve for closing the clutch No valid fault definition CAN J 1939 receive time exceeded message CFG_E Operator unit 2 data Operator unit 2 data Timeout, message location 6 Timeout, message location 6 Angle encoder, steering axle 3, total voltage Pressure in right inner tyre, axle 5 No valid fault definition Operator unit 2 clock Operator unit 2 clock Timeout, message location 7 Timeout, message location 7 Angle encoder, steering axle 3 Page 163 of 276

SPN 03054 03055 03055 03055 03055

Control unit/System TPM EBS EDC6 EDC7 EHLA

03056 03056 03056 03056

EBS EDC6 EDC7 EHLA

03057 03057 03057 03057

EBS EDC6 EDC7 EHLA

03058 03058 03058 03058 03059

EBS EDC6 EDC7 EHLA AST

03059

EBS

03059 03059 03059 03059 03059 03060

EBS_K1 EDC6 EDC7 EHLA EMOS AST

03060 03060 03060 03060 03060 03060 03060 03061

EBS EBS_K1 EDC6 EDC7 EHLA EMOS FFR AST

03061

EBS

03061 03061 03061 03061 03061 03061 03061

EBS_K1 ECAS_4X2 ECAS2_GBV EDC6 EDC7 EHLA EMOS

03061 03062

FFR AST

03062

EBS

03062 03062 03062 03062

EBS_K1 ECAS_4X2 ECAS2_GBV EDC6

SD 812a en-online 05.2007

Fault message Pressure in right outer tyre, axle 5 No valid fault definition Timeout, message location 14 Timeout, message location 14 Angle encoder, steering axle 3, track 1 CAN data bus driveline, receive time exceeded in ERC1_D message from retarder Checksum HW calibration date in serial EEPROM Checksum HW calibration date in serial EEPROM Angle encoder, steering axle 3, track 2 CAN data bus driveline, receive time exceeded in ERC1_E message from retarder Ser. EEPROM data not equal to checksum Ser. EEPROM data not equal to checksum Angle encoder, steering axle 4, differential CAN data bus driveline, receive time exceeded in ERC1_EX message from vehicle management computer Ser. EEPROM: Data main relay monitoring checksum Ser. EEPROM: Data main relay monitoring checksum Angle encoder, steering axle 4, total voltage Checkback power take-off 1 CAN data bus driveline, receive time exceeded in 'High Resolution Vehicle Distance' message from tachograph CAN J 1939 receive time exceeded message HR-VD from tachograph Ser. EEPROM: Data error memory checksum Ser. EEPROM: Data error memory checksum Angle encoder, steering axle 4 Checkback signal PTO1 Checkback power take-off 2 CAN data bus driveline, receive time exceeded in 'Supply pressure' message from the ECAM CAN J 1939 receive time exceeded message ECAM (SP) Ser. EEPROM: Data operating hours counter checksum Ser. EEPROM: Data operating hours counter checksum Angle encoder, steering axle 4, track 1 Checkback signal PTO2 Engine CAN sending message timeout (time overrun). Switch off power take-off 1 CAN data bus driveline, receive time exceeded in EEC3 message from the EDC CAN J 1939 receive time exceeded in message EEC3 from the EDC Interruption in communication Interruption in communication Ser. EEPROM: Actuator test checksum Ser. EEPROM: Actuator test checksum Angle encoder, steering axle 4, track 2 Disengagement fault PTO1 CAN data bus: Time overrun when receiving EDC message engine configuration. Switch off power take-off 2 CAN data bus driveline, receive time exceeded in 'Cruise Control/Vehicle Speed' message from the EDC via vehicle management computer CAN J1939 receive time exceeded message CCVS from the EDC via vehicle management computer CAN message VSC1 CAN message VSC1 Ser. EEPROM: Starter monitoring checksum Page 164 of 276

SPN 03062 03062 03062

Control unit/System EDC7 EHLA EMOS

03062 03063

FFR AST

03063 03063 03063 03063 03063 03063 03063 03063

EBS EBS_K1 ECAS_4X2 ECAS2_GBV EDC6 EDC7 EHLA EMOS

03063 03064

FFR AST

03064 03064 03064 03064 03064 03064 03064

EBS ECAS_4X2 ECAS2_GBV EDC6 EDC7 EHLA EMOS

03064

FFR

03065 03065 03065 03065 03065 03065

EBS ECAS_4X2 ECAS2_GBV EDC6 EDC7 EHLA

03065

FFR

03066 03066 03066 03066 03066 03066

EBS ECAS_4X2 ECAS2_GBV EDC6 EDC7 EHLA

03066

FFR

03067

EBS

03067 03067 03067 03067 03067 03067

EBS_K1 ECAS_4X2 ECAS2_GBV EDC6 EDC7 EHLA

03068 03068 03068 03068

EBS EBS_K1 ECAS_4X2 ECAS2_GBV

SD 812a en-online 05.2007

Fault message Ser. EEPROM: Starter monitoring checksum Angle encoder, front axle, differential Disengagement fault PTO2 CAN data bus: Time overrun when receiving EDC message EDC1. Switch on power take-off 1 CAN data bus driveline, receive time exceeded in vehicle weight measurement message from the ECAS CAN data bus driveline, message VW_ECAS CAN message EEC1 CAN message EEC1 After-run not completed After-run not completed Angle encoder, front axle, total voltage Engagement fault PTO1 CAN data bus: Time overrun when receiving EDC message EDC2. Switch on power take-off 2 CAN data bus driveline, values for vehicle weight in the 'Vehicle Weight' message from the ECAS outside the range CAN message EBC2 CAN message EBC2 Stand alone mode EDC Stand alone mode EDC Angle encoder, front axle Engagement fault PTO2 CAN data bus: Time overrun when receiving EDC message EDC3. CAN data bus driveline, receive time exceeded in TSC1_ACC message from the ACC CAN message FFR_1 CAN message FFR_1 Triggering time individual operation Triggering time individual operation Angle encoder, front axle, track 1 CAN data bus: Time overrun when receiving EDC message EDC4. Driveline CAN databus, receive time exceeded for EEC2 message from the EDC CAN message ECAM_1 CAN message ECAM_1 Time after start Time after start Angle encoder, front axle, track 2 CAN data bus: Time overrun when receiving EDC message EDC5. CAN data bus driveline, receive time exceeded in TCO1 message from tachograph CAN J 1939 receive time exceeded in message TCO1 from the tachograph CAN message EBS (axle load, driven axle) CAN message EBS (axle load, driven axle) Self-test Self-test Angle encoder, joystick, differential CAN data bus driveline, values in 'TCO1 Vehicle Speed' message from tachograph not plausible Impermissible signal TCO1 from the tachograph (road speed) CAN message EBC5 CAN message EBC5 Page 165 of 276

SPN 03068 03068 03068 03069 03069 03069 03069 03069 03069 03069 03070

Control unit/System EDC6 EDC7 EHLA EBS EBS_K1 ECAS_4X2 ECAS2_GBV EDC6 EDC7 EHLA EBS

03070 03070 03070 03070 03070 03070

EBS_K1 ECAS_4X2 ECAS2_GBV EDC6 EDC7 EHLA

03071

EBS

03071 03071 03071 03071

EBS_K1 EDC6 EDC7 EHLA

03072

EBS

03072 03072 03072 03072 03073

EBS_K1 EDC6 EDC7 EHLA EBS

03073 03073 03073 03073 03073 03073 03073 03074 03074 03074 03074 03074 03074 03074 03074 03074 03074 03075

EBS_K1 EDC6 EDC7 EHLA ZH_AT3500_1580 ZH_AT3500_ST ZHZG_9a EBS EBS_K1 ECAS_4X2 ECAS2_GBV EDC6 EDC7 EHLA ZH_AT3500_1580 ZH_AT3500_ST ZHZG_9a EBS

03075 03075 03075 03075 03075

EBS_K1 ECAS_4X2 ECAS2_GBV EDC6 EDC7

SD 812a en-online 05.2007

Fault message Monitoring module defective Monitoring module defective Angle encoder, joystick, total voltage No valid fault definition CAN J 1939 receive time exceeded message TD CAN message EBC1 CAN message EBC1 Redundant speed monitoring Redundant speed monitoring Angle encoder, joystick No valid fault definition CAN J1939 receive time exceeded in message ETC1 from the vehicle management computer Incorrect CAN message time and date Incorrect CAN message time and date Status of plausibility violation Status of plausibility violation Angle encoder, joystick, track 1 CAN data bus driveline, receive time violation in AUX_STAT_ZBR_TR message from the central on-board computer (trailer status information from the central on-board computer) CAN J1939 receive time exceeded in message ETC2 from the vehicle management computer Operating noise analysis Operating noise analysis Angle encoder, joystick, track 2 Driveline CAN databus, receive time exceeded for ETC2 message from VMC CAN J 1939 receive time exceeded in message CFG-MC from the EDC Status of defective cylinders Status of defective cylinders Speed signals, differential Driveline CAN databus, receive time exceeded CAN J 1939 receive time exceeded in message ERC1-MC from the EDC Amount violation sign Amount violation sign Speed signal parameter Control unit fault / incorrect parameter set Control unit defective Control unit fault / incorrect parameter set Driveline CAN databus, receive time exceeded CAN J 1939 receive time exceeded message AS1-ZBR Incorrect CAN message display instrument panel Incorrect CAN message display instrument panel ID number FFR ID number FFR Can message 'Wheel speed information 2' No heating start / no flame formation No heating start No heating start / no flame formation Driveline CAN databus, receive time exceeded CAN J 1939 receive time exceeded message EBC1_x (bus-stop brake) Incorrect CAN message (ASC_2C) Incorrect CAN message (ASC_2C) Fuel pressure sensor (phys.) Fuel pressure sensor (phys.) Page 166 of 276

SPN 03075 03075 03075

Control unit/System ZH_AT3500_1580 ZH_AT3500_ST ZHZG_9a

03076 03076 03076 03076 03076

CNG_ME7 EBS EBS_K1 ECAS_4X2 ECAS2_GBV

03076

EDC6

03076 03076 03076 03076 03076 03076 03077 03077 03077 03077

EDC7 RAS ZH_AT3500_1580 ZH_AT3500_ST ZHZG_9a ZHZG_9c EBS EBS_K1 ECAS_4X2 ECAS2_GBV

03077

EDC6

03077 03077 03077 03077 03077 03077 03077 03078 03078 03078 03078 03078 03078 03078 03078 03078 03079 03079 03079 03079 03079 03079 03079 03080 03080 03080 03080 03080 03080 03080 03080 03080 03080 03081 03081

EDC7 EHLA RAS ZH_AT3500_1580 ZH_AT3500_ST ZHZG_9a ZHZG_9c EBS EBS_K1 ECAS_4X2 ECAS2_GBV EDC6 RAS ZH_AT3500_1580 ZH_AT3500_ST ZHZG_9a EBS ECAS_4X2 ECAS2_GBV EDC6 EDC7 ZH_AT3500_ST ZHZG_9a EBS EBS_K1 ECAS_4X2 ECAS2_GBV EDC6 EDC7 EHLA FFR ZH_AT3500_ST ZHZG_9a EBS EBS_K1

SD 812a en-online 05.2007

Fault message Flame failure (repeated) Flame cut-off Flame failure (repeated) Immobiliser: No quantity due to incorrect vehicle management computer ID Driveline CAN databus, receive time exceeded CAN J 1939 receive time exceeded message ESC1 (NLA) Incorrect CAN message (ASC_2A) Incorrect CAN message (ASC_2A) Immobiliser: No quantity due to incorrect vehicle management computer ID Immobiliser: No quantity due to incorrect vehicle management computer ID Oil level check Undervoltage Voltage Undervoltage Warning short-circuit output fresh air signal Driveline CAN databus, receive time exceeded CAN data bus driveline, message XBR (ACC) Incorrect CAN message (ASC_2B) Incorrect CAN message (ASC_2B) Immobiliser: No quantity due to vehicle management computer ID being 'not ready' for too long Immobiliser: No quantity due to vehicle management computer ID being 'not ready' for too long CAN message 'Tachograph' Comparison between tachometer / EBC speed signal Overvoltage Flame detection before preheating Overvoltage Warning short-circuit output theft alarm No valid fault definition CAN data bus driveline, message ETC7 Incorrect CAN message (ASC_6A) Incorrect CAN message (ASC_6A) Immobiliser: Invalid FR ID after quantity enable CAN signal speed speedometer Premature flame detection LP temperature sensor Premature flame detection No valid fault definition Incorrect CAN message (ASC_6B) Incorrect CAN message (ASC_6B) Governor linkage position Governor linkage position Temperature sensor Circulating pump interruption No valid fault definition Impermissible signal CCVS (parking brake) Incorrect CAN message door status Incorrect CAN message door status ID number of EDC ID number of EDC CAN message CCVS Driveline CAN sending message timeout (time overrun). Metering pump Circulating pump short-circuit No valid fault definition Impermissible signal CCVS (clutch) Page 167 of 276

SPN 03081 03081 03081 03081

Control unit/System ECAS_4X2 ECAS2_GBV EDC6 EDC7

03081 03081 03081 03081 03081 03081 03081 03082 03082 03082 03082 03082 03082 03082

FFR RAS ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c CNG_ME7 EBS EBS_K1 ECAS_4X2 ECAS2_GBV EDC6 EDC7

03082 03082 03082 03082 03082 03082 03082 03082 03083 03083 03083 03083 03083

FFR HYD RAS ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c EBS EBS_K1 EDC6 EDC7 EHLA

03083 03083 03083 03083 03083 03083 03083 03083 03084 03084 03084 03084 03084

FFR HYD RAS ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c EBS EBS_K1 EDC6 EDC7 EHLA

03084 03084 03084 03084 03084 03084 03084 03084 03085 03085 03085 03085

FFR HYD RAS ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c EBS EBS_K1 EDC6 EDC7

SD 812a en-online 05.2007

Fault message Incorrect CAN message TCO 1 Incorrect CAN message TCO 1 Charge air pressure governor shut-off Charge air pressure governor shut-off CAN data bus: Time overrun when receiving EBS message EBC1. CAN signal road speed EBC Temperature sensor interruption Blower motor TRS/TMD mode activated Temperature sensor interruption TRS shut-off Oil pressure sensor plausibility No valid fault definition Impermissible signal EEC1 (rated torque) Incorrect CAN message mileage reading (km) Incorrect CAN message mileage reading (km) Oil pressure sensor plausibility Oil pressure sensor plausibility CAN data bus: Time overrun when receiving EBS message EBC2. Overvoltage shut-off CAN signal engine speed Temperature sensor short-circuit Glow plug / flame watchdog Switch off due to overvoltage Temperature sensor short-circuit Overvoltage shut-off No valid fault definition Impermissible signal EEC1 (actual torque) Rail pressure sensor plausibility Fuel pressure sensor plausibility Speed signal 1 CAN data bus: Time overrun when receiving retarder message EBC3. Undervoltage shut-off CAN signal weight Metering pump interruption Overheating Switch off due to undervoltage Metering pump interruption Undervoltage shut-off No valid fault definition Impermissible signal EEC1 (engine revs) Stop position test, governor linkage Stop position test, governor linkage Speed signal 2 CAN data bus: Time overrun when receiving EBS message ERC1_RD. Overheating on overheating sensor CAN signal lifting axle Metering pump short-circuit Overheating sensor Overheating software threshold Metering pump short-circuit Overheating on overheating sensor No valid fault definition Impermissible signal EEC2 (idling speed switch) FFR3: Vehicle distance invalid FFR3: Vehicle distance invalid Page 168 of 276

SPN 03085 03085 03085 03085 03085 03085 03086 03086 03086 03086 03086 03086

Control unit/System EHLA RAS ZH_AT3500_1580 ZH_AT3500_ST ZHZG_9a ZHZG_9c CNG_ME7 EBS EBS_K1 EDC6 EDC7 EHLA

03086

FFR

03086 03086 03086 03086 03086 03086 03087 03087 03087 03087 03087

HYD RAS ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a EBS EBS_K1 EDC6 EDC7 EHLA

03087 03087 03087 03087 03087 03087 03087 03087 03088 03088

FFR HYD RAS ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c EBS EBS_K1

03088

EDC6

03088

EDC7

03088 03088 03088 03088 03088 03089 03089 03089 03089

FFR HYD ZH_AT3500_1580 ZH_AT3500_ST ZHZG_9a EBS EBS_K1 EDC6 EDC7

03089 03089 03089 03089 03089 03090 03090 03090

FFR ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a AST EBS EBS_K1

SD 812a en-online 05.2007

Fault message Speed signal 3 CAN signal parking brake Blower motor interruption Setpoint potentiometer discontinuity Blower motor interruption Overheating on flame sensor Monitoring exhaust gas recirculation throughflow No valid fault definition Impermissible signal EEC2 (accelerator pedal position) Exhaust gas recirculation actuator position limit Exhaust gas recirculation actuator position limit Speed signals CAN data bus: Time overrun when receiving Astronic message ETC1. Temperature difference between temperature governing sensor and overheating sensor CAN signal bus transmitter/receiver Blower motor short-circuit Blower relay short-circuit Overheating differential evaluation Blower motor short-circuit No valid fault definition Impermissible signal EEC3 (nom. friction torque) Oil pressure sensor Oil pressure sensor Speed signals, differential CAN data bus: Time overrun when receiving Astronic message ETC2. Overheated too frequently Parameter value calibration Blower motor EMK fault Battery isolator short-circuit Overheating operation interlock Glow plug / flame watchdog interruption Overheated too frequently No valid fault definition Impermissible signal ERC1_MC (ret. mode) Boost pressure sensor after cooler (before exhaust gas recirculation) Boost pressure sensor after cooler (before exhaust gas recirculation) CAN data bus: Time overrun when receiving tachograph message TCO1. Flame in post-operation too frequently Glow plug / flame watchdog interruption Incorrect application / impermissible air blockage Glow plug / flame watchdog short-circuit No valid fault definition Impermissible signal ERC1_MC (ret. torque) Charge air temperature sensor Boost air temperature sensor upstream of cylinder inlet CAN data bus: Time overrun when receiving central on-board computer message Veh_Dist. Glow plug / flame watchdog short-circuit Incorrect overheating sensor position (OHS degree too low) Overheating hardware Overheating ECU (communication controllers 1 + 2) No valid fault definition Impermissible signal ETC1 (driveline) Page 169 of 276

SPN 03090

Control unit/System EHLA

03090 03090 03090 03090 03091 03091 03091 03091 03091 03091 03091

FFR ZH_AT3500_1580 ZH_AT3500_ST ZHZG_9a AST EBS EBS_K1 EDC6 EDC7 EHLA EMOS

03091 03091 03091 03091 03092 03092 03092 03092 03092

FFR ZH_AT3500_1580 ZH_AT3500_ST ZHZG_9a EBS EBS_K1 EDC6 EDC7 EHLA

03092 03092 03092 03092 03092 03092 03092 03093 03093 03093 03093 03093

FFR HYD ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9a ZHZG_9c EBS EBS_K1 EDC6 EDC7 EHLA

03093 03093 03093 03093 03093 03093 03094 03094 03094 03094 03094

FFR HYD ZH_AT3500_1580 ZH_AT3500_ST ZH_D5W_SC ZHZG_9c EBS EBS_K1 EDC6 EDC7 EHLA

03094 03094 03095 03095 03095 03095 03095

FFR ZH_AT3500_ST EBS EBS_K1 EDC6 EDC7 EHLA

03095 03095 03096

FFR ZH_AT3500_ST EBS

SD 812a en-online 05.2007

Fault message Axle monitoring parameter CAN data bus: Time overrun when receiving central on-board computer message Time/Date. Overheating on overheating sensor Heater interlock Redundant temperature sensor has tripped CAN data bus EBS1 from EBS, EBC1 No valid fault definition Impermissible signal ETC2 (gear information) Cooling water temperature sensor Cooling water temperature sensor Inverse movement on steering axle 1 Timeout of EBC1 message CAN data bus: Time overrun when receiving retarder message RE_Fluids. Overheating sensor short-circuit Heater interlock permanent Battery isolator short-circuit No valid fault definition Impermissible signal SP (reservoir circuit 1) Time/date: Timeout, Time/date: Timeout, System deviation on steering axle 1 CAN data bus: Time overrun when receiving retarder message RD_Fluids. Ignition sparker discontinuity Overheating sensor interruption Overheating sensor interruption Interruption glow plug Vehicle blower output short-circuit Glow plug interruption or short-circuit No valid fault definition Impermissible signal SP (reservoir circuit 2) TIME/DATE: reserved Bits & Bytes TIME/DATE: reserved Bits & Bytes Large system deviation on steering axle 1 CAN data bus: Time overrun when receiving Astronic message TSC1_TE. Ignition sparker short circuit Setpoint sensor interruption Setpoint sensor interruption Overload glow plug output Glow plug output overload No valid fault definition Impermissible signal CFG_MC (ref. ret. torque) Timeout message position 8 Timeout message position 8 Inverse movement on steering axle 2 CAN data bus: Time overrun when receiving EBS message TSC1_AE. Blower relay short-circuit No valid fault definition Impermissible signal CFG_E (ref. motor torque) Percentage quantity setpoint Percentage quantity setpoint System deviation on steering axle 2 CAN data bus: Time overrun when receiving EBS message Veh_weight. Battery isolator short-circuit No valid fault definition Page 170 of 276

SPN

Control unit/System

03096 03096 03096 03096

EBS_K1 EDC6 EDC7 EHLA

03096 03096 03097

FFR ZH_AT3500_ST EBS

03097 03097 03097 03097

EBS_K1 EDC6 EDC7 EHLA

03097 03097 03097 03097 03098

FFR HYD ZH_AT3500_ST ZHZG_9c EBS

03098 03098 03098 03098

EBS_K1 EDC6 EDC7 EHLA

03098 03098 03099 03099

FFR ZH_AT3500_ST AST EBS

03099 03099 03099 03099

EBS_K1 EDC6 EDC7 EHLA

03099 03099 03100 03100 03100 03100 03100 03100 03100 03100 03101 03101

FFR ZH_AT3500_ST BHTC CRT EBS EDC6 EDC7 EHLA FFR ZH_AT3500_ST AST CRT

03101 03101 03101 03101 03101 03101 03101 03101 03102 03102 03102

EBS EBS_K1 ECAS_4X2 ECAS2_GBV EHLA EMOS FFR ZH_AT3500_ST AST CNG_ME7 CRT

SD 812a en-online 05.2007

Fault message CAN data bus driveline, 'Lighting on trailer 1 detected' in message AS1_ZBR Accelerator pedal Accelerator pedal Large system deviation on steering axle 2 CAN data bus: Time overrun when receiving central on-board computer message AUX-STAT-ZBR1. Flame failure (no restart) No valid fault definition CAN data bus driveline, 'Actual Inner Wheel Steering Angle' in message ESC1 (steering angle) Fuel temperature sensor Fuel temperature sensor Inverse movement on steering axle 3 CAN data bus: Time overrun when receiving ECAS message ECAS1. Diagnostic output short-circuit to +Ub Blower motor blockage protection Diagnostic output short-circuit to +Ub No valid fault definition CAN data bus driveline, 'Steering axle status' in message ESC1 Control path: Loose contact Control path: Loose contact System deviation on steering axle 3 CAN databus: Time overrun when receiving message ERC1_RE. Incorrect application / impermissible air blockage Output speed 1 No valid fault definition CAN data bus driveline, 'Percentage clutch slip' in message ETC1 Fuel pressure sensor Fuel pressure sensor (rail pressure) Large system deviation on steering axle 3 CAN data bus: Time overrun when receiving ECAM message ECAM1. Incorrect overheating sensor position (OHS degree too low) Main pump Exhaust differential pressure via the CRT filter Pressure control module, left front axle, no fault Fuel supply pressure sensor Fuel supply pressure sensor Inverse movement on steering axle 4 CAN data bus: EDC message EDC1, byte 1 Heater interlock Output speeds 1+ 2 Exhaust temperature in front of the CRT filter Pressure control module, left front axle, interruption, short-circuit wheel sensor A (!) Wheel sensor left front axle Travel sensor left REAR AXLE Height sensor FRONT AXLE left System deviation on steering axle 4 Gearbox output signal CAN data bus: EDC message EDC1, byte 2 Heater interlock permanent Gearbox input and output speeds Exhaust gas recirculation valve output stage Current engine torque Page 171 of 276

SPN

Control unit/System

03102 03102 03102 03102 03102 03102 03102 03102 03102 03103 03103 03103

EBS ECAS_4X2 ECAS2_GBV EDC6 EDC7 EHLA FFR ZBR2 ZH_D5W_SC AST CNG_ME7 CRT

03103 03103 03103 03103 03103 03103 03103 03103 03104

EBS ECAS_4X2 ECAS2_GBV EHLA FFR OBDU ZBR2 ZH_D5W_SC CNG_ME7

03104 03104 03104 03104 03104 03104 03104 03105

EBS ECAS_4X2 EHLA FFR HYD ZBR2 ZH_D5W_SC CNG_ME7

03105 03105 03105 03105 03105 03105 03106

EBS EHLA FFR HYD OBDU ZHZG_9c CNG_ME7

03106 03106 03106 03106 03107 03107

EBS EHLA FFR OBDU AST CNG_ME7

03107 03107 03107 03107 03107 03108

EBS EBS_K1 EHLA FFR ZBR2 CNG_ME7

03108 03108 03108 03108

EBS EHLA FFR ZBR2

SD 812a en-online 05.2007

Fault message Pressure control module, left front axle, wheel sensor A: Delay too long Travel sensor right REAR AXLE Height sensor, FRONT AXLE right Exhaust gas recirculation system output stage Exhaust gas recirculation system output stage Large system deviation on steering axle 4 CAN data bus: EDC message EDC1, byte 3 ZBR power supply Burner motor EMK outside permitted range CAN data bus vehicle speed from EDC Lambda probe before catalytic converter (bank 1) Status of the regeneration logic Pressure control module, left front axle, wheel sensor A: Moving off fault Travel sensor FRONT AXLE CENTRE AXLE height sensor Calibration mode when vehicle moving CAN data bus: EDC message EDC1, bytes 4 and 5 Tension V-belt Analog ground Burner motor interruption Lambda probe heating before catalytic converter (bank 1) Pressure control module, left front axle, wheel sensor A: Clearance too great Travel sensor, front axle Calibration data steering axle 1 CAN data bus: EDC message EDC1, bytes 6 and 7 Burner motor stage 1 does not turn (low) Analog ground Burner motor short circuit Lambda control adaptation multi (bank 1) Pressure control module, left front axle, perpetual control wheel sensor A Calibration data steering axle 2 CAN data bus: EDC message EDC1, byte 8 Burner motor stage 2 does not turn (high) Water pump V-belt torn Burner motor not turning Idling speed control, nominal speed Pressure control module, left front axle, long instability wheel sensor A Calibration data steering axle 3 CAN data bus: EDC message EDC2, bytes 1 and 2 Cooling defective: Water temperature gradient too steep Voltage (clutch sensor) Total exhaust-relevant errors (ASE) Pressure control module, left front axle, pulse ring fault wheel sensor A (!) Impulse wheel fault left front axle Calibration data steering axle 4 CAN data bus: EDC message EDC2, bytes 3 and 4 Ignition ON (relay tl. 15) Gas system pressure Pressure control module, left front axle, fault on lifting axle wheel sensor A Calibration data front axle CAN data bus: EDC message EDC2, bytes 5 and 6 Electrical battery master switch/parking brake sensor Page 172 of 276

SPN

Control unit/System

03109 03109 03109 03109 03109 03109 03110 03110

EBS EBS_K1 EHLA FFR HYD ZBRO BHTC CNG_ME7

03110 03110 03110 03110 03110 03110

EBS EHLA FFR HYD ZBRO ZH_D5W_SC

03111 03111

AST CNG_ME7

03111 03111 03111 03111 03111 03111 03111 03111

EBS EHLA EMOS FFR HYD TPM ZBR2 ZH_D5W_SC

03112 03112

AST CNG_ME7

03112 03112 03112 03112 03112

EBS EHLA FFR TPM ZBRO

03113

AST

03113 03113 03113 03113 03113 03113

EBS EHLA FFR TPM ZBRO ZH_D5W_SC

03114 03114 03114 03114 03114 03114

EBS EHLA FFR TPM ZBRO ZH_D5W_SC

03115 03115 03115 03115

EBS EHLA FFR ZBRO

03116

EBS

SD 812a en-online 05.2007

Fault message Pressure control module, left front axle, no valid fault definition (!) Brake/impulse wheel/sensor combination left front axle Calibration data joystick CAN data bus: EDC message EDC2, bytes 7 and 8 Water pump malfunction or fuse blown Ignition lock radio position Recirculating pump Engine speed sensor crankshaft toothed disc Pressure control module, left front axle, no valid fault definition Number of CAN objects CAN data bus: EDC message EDC3, bytes 1 and 2 Vehicle blower control discontinuity Ignition lock ignition on Vehicle blower relay interruption CAN data bus message timeout time/date information from central on-board computer ZBR2, TIME/DATE Reference mark sensor Pressure control module, left front axle, interruption, short-circuit wheel sensor B CAN bus off Timeout of Time_Date message CAN data bus: EDC message EDC3, bytes 3 and 4 Vehicle blower control short circuit Slight leakage from left outer tyre, axle 1 Ignition lock starter tl. 50 Vehicle blower relay short-circuit CAN data bus signal error time/date information from central onboard computer ZBR2, TIME/DATE Phase sensor Pressure control module, left front axle, wheel sensor B: Delay too long CAN data has been falsified CAN data bus: EDC message EDC3, byte 5 Slight leakage from left inner tyre, axle 1 Ignition lock ignition off CAN data bus message timeout retarder configuration, Ret_Conf (driveline retarder configuration) Pressure control module, left front axle, wheel sensor B: Moving off fault CAN bus off CAN data bus: EDC message EDC3, byte 6 Slight leakage from right inner tyre, axle 1 Battery undervoltage Water pump interruption Pressure control module, left front axle, wheel sensor B: Clearance too great Steering wheel sensor - not used CAN data bus: EDC message EDC3, byte 7 Slight leakage from right outer tyre, axle 1 Battery master switch Water pump short-circuit Pressure control module, left front axle, perpetual control wheel sensor B Steering wheel sensor - operating CAN data bus: EDC message EDC3, byte 8 Battery main relay Pressure control module, left front axle, long instability wheel sensor B Page 173 of 276

SPN 03116 03116 03116 03117

Control unit/System FFR HYD ZBRO AST

03117 03117 03117 03117 03118

EBS FFR HYD ZBRO AST

03118

EBS

03118 03118 03118 03118 03119 03119

EMOS FFR HYD ZBRO AST CNG_ME7

03119

EBS

03119 03119 03119 03119 03119 03119 03120 03120

EMOS FFR HYD ZBRO ZH_D5W_SC ZHZG_9c AST BHTC

03120

EBS

03120 03120 03120 03120 03120 03120 03120 03121 03121

EBS_K1 EHLA FFR HYD ZBRO ZH_D5W_SC ZHZG_9c AST CNG_ME7

03121 03121 03121 03121 03121 03121 03121 03122 03122

EBS EBS_K1 EHLA FFR HYD TPM ZBRO AST CNG_ME7

03122 03122 03122 03122 03122 03122 03122

EBS EHLA FFR HYD TPM ZBRO ZH_D5W_SC

SD 812a en-online 05.2007

Fault message CAN data bus: EDC message EDC4, byte 1 Water pump relay coil discontinuity Ignition on Clutch self-adjustment faulty Pressure control module, left front axle, pulse ring fault wheel sensor B CAN data bus: EDC message EDC4, byte 2 Water pump relay coil short circuit Ignition on Clutch does not open Pressure control module, left front axle, fault on lifting axle wheel sensor B Clutch regulator switched on but no clutch opening valve available for opening clutch CAN data bus: EDC message EDC4, byte 3 Solenoid valve discontinuity Ignition on check Clutch does not close / does not transmit torque Altitude sensor Pressure control module, left front axle, no valid fault definition Clutch regulator switched on but no clutch closing valve available for closing clutch CAN data bus: EDC message EDC4, byte 4 Solenoid valve short circuit Battery master switch 1 Metering pump short-circuit Metering pump short-circuit or overload Mechanical fault (small valve for opening the clutch) LIN bus Pressure control module, left front axle, electrical power supply fault, pad wear sensor Electrical power supply pad wear sensor (front axle left or front axle) Joystick CAN data bus: EDC message EDC4, bytes 5 and 6 Jet carrier preheater relay coil discontinuity Battery master switch 3 Metering pump interruption Metering pump interruption Mechanical fault (small valve for closing the clutch) Ignition output stage cylinder 1 Pressure control module, left front axle, pad wear sensor A outside permitted value range Pad wear sensor A (front axle left) outside valid range Joystick both sides CAN data bus: EDC message EDC4, byte 7 Jet carrier preheater relay coil short circuit Slight leakage from left outer tyre, axle 2 Battery master switch 4 Mechanical fault (large valve for opening the clutch) Ignition output stage cylinder 2 Pressure control module, left front axle, pad wear sensor B outside permitted value range Joystick, sustained operation CAN data bus: EDC message EDC4, byte 8 Too many unsuccessful start attempts Slight leakage from left inner tyre, axle 2 Starting assistance Operation interlock safety time 1 Page 174 of 276

SPN 03122 03123 03123

Control unit/System ZHZG_9c AST CNG_ME7

03123

EBS

03123 03123 03123 03123 03123 03123 03123 03124 03124

EBS_K1 FFR HYD TPM ZBRO ZH_D5W_SC ZHZG_9c AST CNG_ME7

03124 03124 03124 03124 03124 03124 03124 03124 03124 03125 03125 03125 03125 03125 03125 03126 03126

EBS EHLA EMOS FFR HYD TPM ZBRO ZH_D5W_SC ZHZG_9c AST CNG_ME7 EBS EHLA FFR ZHZG_9c AST CNG_ME7

03126 03126 03126 03126 03126 03126 03127

EBS EHLA FFR HYD ZH_D5W_SC ZHZG_9c AST

03127 03127 03127 03127 03127 03128

EBS EHLA EMOS FFR ZHZG_9c AST

03128 03128 03128 03128 03128 03129

EBS EHLA FFR ZH_D5W_SC ZHZG_9c AST

03129 03129

EBS EHLA

03129

FFR

SD 812a en-online 05.2007

Fault message Too many unsuccessful start attempts Mechanical fault (large valve for closing the clutch) Ignition output stage cylinder 3 Pressure control module, left front axle, pressure sensor outside permitted value range (!) Pressure sensor (left front axle or front axle) outside valid range CAN data bus: EDC message EDC5, byte 1 Flame sensor: 'Flame before fuel' Slight leakage from right inner tyre, axle 2 Starting assistance check Cold blowing time exceeded Flame present during switch-on Clutch travel fault Ignition output stage cylinder 4 Pressure control module, left front axle, time for 'Current pressure' inquiry too long Configuration of axle count Clutch travel sensor signal CAN data bus: EDC message EDC5, byte 2 No start – safety time exceeded Slight leakage from right outer tyre, axle 2 Ignition on switched off Safety time exceeded No start – safety time exceeded Pressure limiting valve fault Ignition output stage cylinder 5 Pressure control module, left front axle, poor ventilation Locking monitoring steering axle 1 CAN data bus: EDC message EDC5, bytes 3 and 4 Flame failure from start power Pressure signal faulty Ignition output stage cylinder 6 Pressure control module, left front axle, excessive pressure during pulse test Steering axle 1 has moved out of locking position CAN data bus: EDC message EDC5, byte 5 too many flame cut-outs / time Flame failure from governor stage 'HIGH' Flame failure from high power ECU temperature fault Pressure control module, left front axle, residual pressure after braking Locking monitoring steering axle 2 'Temperature sensor next to processor' signal CAN data bus: EDC message EDC5, bytes 6 and 7 Flame failure from medium power Oil temperature signal fault Pressure control module, left front axle, pressure sensor fault without braking Steering axle 2 has moved out of locking position CAN data bus: EDC message EDC5, byte 8 Flame failure from governor stage 'LOW' Flame failure from low power No signal from shift transmitter main gearbox Pressure control module, left front axle, no valid fault definition Locking monitoring steering axle 3 CAN data bus: EDC message engine configuration, bytes 0 and 1 Page 175 of 276

SPN 03130

Control unit/System BHTC

03130 03130 03130 03130

EBS EHLA FFR HYD

03131 03131 03131

EBS EBS_K1 EHLA

03131 03131 03132

FFR TPM AST

03132 03132 03132 03132 03132 03132 03132 03132 03133

EBS EBS_K1 EHLA FFR HYD TPM ZH_D5W_SC ZHZG_9c AST

03133 03133

EBS EHLA

03133 03133 03133 03133 03133

FFR HYD TPM ZH_D5W_SC ZHZG_9c

03134 03134 03134 03134 03134 03134

EBS EBS_K1 EHLA FFR TPM ZHZG_9c

03135 03135

EBS EHLA

03135 03135 03136

FFR ZHZG_9c AST

03136

EBS

03136 03136 03136 03136 03136 03137

EBS_K1 EHLA FFR ZH_D5W_SC ZHZG_9c AST

03137 03137

EBS EHLA

SD 812a en-online 05.2007

Fault message Refrigerant pressure Pressure control module, left front axle, wheel sensor IC defective Steering axle 3 has moved out of locking position CAN data bus: EDC message engine configuration, byte 2 Flame not extinguished in post-operation Pressure control module, left front axle, faulty backup valve checkback Backup valve checkback (front axle left or front axle) Locking monitoring steering axle 4 CAN data bus: EDC message engine configuration, bytes 3 and 4 Slight leakage from left outer tyre, axle 3 Shift transmitter self-adjustment fault Pressure control module, left front axle, faulty intake valve checkback Intake valve checkback (ABS valve front axle left) Steering axle 4 has moved out of locking position CAN data bus: EDC message engine configuration, byte 5 Temperature governor sensor discontinuity Slight leakage from left inner tyre, axle 3 Interruption governor sensor External temperature governor sensor interruption Gate selection transmitter signal Pressure control module, left front axle, faulty intake and backup valve checkback Actuator test steering axle 1 CAN data bus: EDC message engine configuration, bytes 6 and 7 Temperature governor sensor short circuit Slight leakage from right inner tyre, axle 3 Short-circuit governor sensor External temperature governor sensor short-circuit Pressure control module, left front axle, faulty outlet valve checkback Exhaust valve checkback (ABS valve front axle left) Actuator test steering axle 2 CAN data bus: EDC message engine configuration, byte 8 Slight leakage from right outer tyre, axle 3 Setpoint sensor interruption Pressure control module, left front axle, faulty outlet and backup valve checkback Actuator test steering axle 3 CAN data bus: EDC message engine configuration, bytes 9 and 10 Setpoint sensor short-circuit Teach-in fault, gate selection transmitter signal Pressure control module, left front axle, faulty outlet and intake valve checkback Exhaust and intake valve checkback (ABS valve front axle left) Actuator test steering axle 4 CAN data bus: EDC message engine configuration, byte 11 Interruption flame sensor Flame sensor interruption Range-change group travel sensor signal Pressure control module, left front axle, faulty outlet and intake and backup valve checkback Digital input parameters Page 176 of 276

SPN

Control unit/System

03137 03137 03137

FFR ZH_D5W_SC ZHZG_9c

03138 03138 03138 03138

EBS EBS_K1 EHLA FFR

Pressure control module, left front axle, no valid fault definition Proportional valve (front axle left or front axle) Digital input parameters CAN data bus: EDC message engine configuration, byte 14

03139 03139 03139

EBS EBS_K1 EHLA

03139 03140 03140

FFR AST BHTC

03140

EBS

03140 03141

FFR AST

Pressure control module, left front axle, no valid fault definition ABS valves (front axle) Analog inputs CAN data bus: EDC message engine configuration, bytes 15 and 16 Teach-in fault, range-change group travel sensor Calibration Pressure control module, left front axle, no CAN reception from module CAN data bus: EDC message engine configuration, bytes 17 and 18 No travel sensor signal from splitter

03141

CNG_ME7

03141 03141

EBS EHLA

03141 03141

FFR TPM

Pressure control module, left front axle, software incompatibility between control unit and pressure control module Digital CAN input parameters CAN data bus: EDC message engine configuration, bytes 19 and 20 Slight leakage from left outer tyre, axle 4

03142

CNG_ME7

Total exhaust-relevant errors (ASE) cylinder 2, exhaust-relevant

03142

EBS

03142 03142

FFR TPM

03143

CNG_ME7

03143 03143 03143 03143 03143 03143 03143 03144

EBS EHLA FFR HYD TPM ZH_D5W_SC ZHZG_9c AST

03144

CNG_ME7

03144 03144 03144 03144 03144 03144 03145

EBS EHLA HYD TPM ZH_D5W_SC ZHZG_9c AST

SD 812a en-online 05.2007

Fault message CAN data bus: EDC message engine configuration, bytes 12 and 13 Short-circuit flame sensor Flame sensor short-circuit

Total exhaust-relevant errors (ASE) cylinder 1, exhaust-relevant

Pressure control module, left front axle, 12/24 volt incompatibility between control unit and pressure control module CAN data bus: EDC message engine configuration, bytes 21 and 22 Slight leakage from left inner tyre, axle 4 Total exhaust-relevant errors (ASE) cylinder 3, exhaust-relevant Pressure control module, left front axle, high cycle protection intake valve active, pressure < 4 bar Digital CAN output parameters CAN data bus: EDC message engine configuration, byte 23 Overheating sensor discontinuity Slight leakage from right inner tyre, axle 4 Interruption overheating sensor Overheating sensor interruption Self-adjustment fault, travel sensor signal from splitter Total exhaust-relevant errors (ASE) cylinder 4, exhaust-relevant Pressure control module, left front axle, arithmetic test not successful Prop. valve steering axle 1, incorrect movement direction Overheating sensor short circuit Slight leakage from right outer tyre, axle 4 Short-circuit overheating sensor Overheating sensor short-circuit Range-change group does not disengage Page 177 of 276

SPN

Control unit/System

03145

CNG_ME7

03145 03145 03146

EBS EHLA AST

03146

CNG_ME7

03146 03146 03147

EBS EHLA AST

03147 03147 03148

EBS EHLA AST

03148 03148 03149

EBS EHLA AST

03149 03149 03149 03150 03150 03150 03150 03150 03151

EBS EBS_K1 EHLA AST BHTC EBS EHLA FFR AST

03151 03151 03151 03151 03151 03151 03151 03152

EBS EBS_K1 ECAS_4X2 ECAS2_GBV EHLA FFR TPM AST

03152 03152 03152 03152 03152 03152 03153

EBS ECAS_4X2 ECAS2_GBV FFR HYD TPM AST

03153 03153 03153 03153 03153 03153 03154

EBS ECAS_4X2 ECAS2_GBV FFR HYD TPM AST

03154 03154 03154 03154

EBS ECAS_4X2 FFR HYD

SD 812a en-online 05.2007

Fault message Total exhaust-relevant errors (ASE) cylinder 5, exhaust-relevant Pressure control module, left front axle, wheel compensation fault wheel sensor A Prop. valve steering axle 1, deviation Changeover fault with range-change group shift Total exhaust-relevant errors (ASE) cylinder 6, exhaust-relevant Pressure control module, left front axle, wheel compensation fault wheel sensor B Prop. valve steering axle 2, incorrect movement direction Range-change group does not engage Pressure control module, left front axle, electrical power supply fault, axle load sensor Prop. valve steering axle 2, deviation Splitter does not disengage Pressure control module, left front axle, pressure differential on pressure control module pair, front axle Prop. valve steering axle 3, incorrect movement direction Changeover fault with splitter shift Pressure control module, left front axle, no valid fault definition (!) Pneumatic redundant path front axle Prop. valve steering axle 3, deviation Splitter group does not engage Different variant control unit control element Pressure control module, right front axle, no fault Prop. valve steering axle 4, incorrect movement direction CAN data bus: EBS message EBC1, byte 1 Selector cylinder does not open Pressure control module, right front axle, interruption, shortcircuit wheel sensor A (!) Wheel sensor right front axle Pressure sensor left REAR AXLE Pressure sensor FRONT AXLE left Prop. valve steering axle 4, deviation CAN data bus: EBS message EBC1, byte 2 Slight leakage from left outer tyre, axle 5 Gate shift fault Pressure control module, right front axle, wheel sensor A: Delay too long Pressure sensor right REAR AXLE Pressure sensor FRONT AXLE right CAN data bus: EBS message EBC1, byte 3 Combustion display discontinuity Slight leakage from left inner tyre, axle 5 Selector cylinder does not close Pressure control module, right front axle, wheel sensor A: Moving off fault Pressure sensor FRONT AXLE Pressure sensor CENTRE AXLE CAN data bus: EBS message EBC1, byte 4 Combustion display short circuit Slight leakage from right inner tyre, axle 5 Main gearbox gear does not disengage Pressure control module, right front axle, wheel sensor A: Clearance too great Pressure sensor front axle CAN data bus: EBS message EBC1, byte 5 Malfunction display discontinuity Page 178 of 276

SPN 03154 03155

Control unit/System TPM AST

03155 03155 03155 03155 03156

EBS ECAS_4X2 FFR HYD AST

03156 03156 03156

EBS ECAS_4X2 FFR

03157 03157 03157 03157 03157 03158

EBS EBS_K1 ECAS_4X2 ECAS2_GBV FFR AST

03158 03158 03158 03158 03159

EBS ECAS_4X2 ECAS2_GBV FFR AST

03159 03159 03159 03160 03160

EBS EBS_K1 FFR AST BHTC

03160 03160

EBS FFR

03161 03161 03161

EBS EHLA FFR

03162 03162 03162 03163

EBS EHLA FFR AST

03163 03163 03163 03163

EBS EHLA FFR HYD

03164

AST

03164 03164 03164 03164 03164 03164

EBS EHLA FFR HYD ZH_D5W_SC ZHZG_9c

03165

EBS

SD 812a en-online 05.2007

Fault message Slight leakage from right outer tyre, axle 5 Main gearbox gear does not engage Pressure control module, right front axle, perpetual control wheel sensor A Pressure sensor 2nd right REAR AXLE CAN data bus: EBS message EBC2, bytes 1 and 2 Malfunction display short circuit Wrong gear selected in main gearbox Pressure control module, right front axle, long instability wheel sensor A Pressure sensor 2nd left REAR AXLE CAN data bus: EBS message EBC2, byte 3 Pressure control module, right front axle, pulse ring fault wheel sensor A (!) Impulse wheel fault right front axle Pressure sensor, brake Pressure sensor, brake CAN data bus: EBS message EBC2, byte 4 Shift sensor signal continuously active Pressure control module, right front axle, fault on lifting axle wheel sensor A Pressure sensor lifting axle Pressure sensor lifting axle CAN data bus: EBS message EBC2, byte 5 Range-change group shift sensor signal continuously active Pressure control module, right front axle, no valid fault definition (!) Brake/impulse wheel/sensor combination right front axle CAN data bus: EBS message EBC2, byte 6 Splitter shift sensor signal continuously active Control element tl30 voltage Pressure control module, right front axle, no valid fault definition CAN data bus: EBS message EBC2, byte 7 Pressure control module, right front axle, interruption, shortcircuit wheel sensor B Recirculating/centring valve CAN data bus: EBS message EBC2, byte 8 Pressure control module, right front axle, wheel sensor B: Delay too long Digital output 2 CAN data bus: EBS message EBC3, byte 0 Engine does not react to torque specification Pressure control module, right front axle, wheel sensor B: Moving off fault Digital output 3 CAN data bus: EBS message EBC3, byte 1 Control unit reset CAN data bus electronic engine governor 1 from EDC, EEC1 (accelerator pedal position, drivers demand engine percent torque) Pressure control module, right front axle, wheel sensor B: Clearance too great Digital output 4 CAN data bus: EBS message EBC3, byte 2 Control unit failure (ROM fault) ROM fault Control unit failure (ROM fault) Pressure control module, right front axle, perpetual control wheel sensor B Page 179 of 276

SPN 03165 03165 03165 03165 03165 03166

Control unit/System EHLA FFR HYD ZH_D5W_SC ZHZG_9c AST

03166 03166 03166 03166 03166

EBS EHLA FFR HYD ZHZG_9c

03167 03167 03167

EBS EHLA FFR

03168 03168 03168 03168 03169

EBS EHLA FFR ZHZG_9c AST

03169 03169 03169 03169

EBS EHLA FFR HYD

03170

AST

03170 03170 03170 03170 03170

EBS ECAS_4X2 ECAS2_GBV EHLA FFR

03171 03171

AST CNG_ME7

03171 03171 03171 03171 03171 03171 03171 03171

EBS EBS_K1 EDC6 EDC7 EHLA FFR ZH_D5W_SC ZHZG_9c

03172 03172 03172 03172

EBS EHLA FFR ZH_D5W_SC

03173 03173 03173

EBS EHLA FFR

03174 03174 03174

EBS EHLA FFR

SD 812a en-online 05.2007

Fault message Digital output 5 CAN data bus: EBS message EBC3, byte 3 Control unit failure (RAM fault) RAM fault Control unit failure (RAM fault) Permanent idling speed signal Pressure control module, right front axle, long instability wheel sensor B Digital output 6 CAN data bus: EBS message EBC3, byte 4 Control unit failure (EEPROM fault) Control unit failure (EEPROM fault) Pressure control module, right front axle, pulse ring fault wheel sensor A Digital output 7 CAN data bus: EBS message EBC3, byte 5 Pressure control module, right front axle, fault on lifting axle wheel sensor B Digital output 8 CAN data bus: EBS message EBC3, byte 6 Internal temperature governor sensor defective Shut-off relay in ECU does not switch off Pressure control module, right front axle, no valid fault definition Digital output 9 CAN data bus: EBS message EBC3, byte 7 Control unit: general fault No electrical power supply at terminal 30 or shut-off relay in ECU does not switch on Pressure control module, right front axle, electrical power supply fault, pad wear sensor Steering angle sensor Steering angle sensor Digital output 10 CAN data bus: EBS message EBC4, byte 1 CAN data bus electronic engine governor 1 from EDC, EEC1 (engine torque, actual engine percent torque) Charge pressure control valve Pressure control module, right front axle, pad wear sensor A outside permitted value range Pad wear sensor A (front axle right) outside valid range Boost pressure switch output stage Boost pressure switch output stage Digital output 11 CAN data bus: EBS message EBC4, byte 2 EEPROM checksum error GK output stage transistor failed Pressure control module, right front axle, pad wear sensor B outside permitted value range Digital output 12 CAN data bus: EBS message EBC4, byte 3 EEPROM timeout error Pressure control module, right front axle, pressure sensor outside permitted value range Digital output 13 CAN data bus: EBS message EBC4, byte 4 Pressure control module, right front axle, time for 'Current pressure' inquiry too long Digital output 14 CAN data bus: EBS message EBC4, byte 5 Page 180 of 276

SPN 03175 03175 03175 03175 03175

Control unit/System AST EBS EHLA EMOS FFR

03176 03176 03177

EBS FFR AST

03177 03177 03177 03178

EBS EMOS FFR AST

03178 03178 03179

EBS FFR AST

03179 03179 03180

EBS FFR AST

03180 03180 03180 03181

EBS EMOS FFR AST

03181

CNG_ME7

03181 03181 03181 03181 03182

EBS EHLA EMOS FFR AST

03182

CNG_ME7

03182 03182 03182 03182 03182

EBS EBS_K1 EHLA EMOS FFR

03183

AST

03183

CNG_ME7

03183 03183 03183 03184

EBS EHLA FFR AST

03184

CNG_ME7

03184 03184 03184 03184 03185

EBS EBS_K1 EHLA FFR AST

SD 812a en-online 05.2007

Fault message Ignition lock signal fault (terminal 15) Pressure control module, right front axle, poor ventilation Digital output 15 Drop-out of ignition signal CAN data bus: EBS message EBC4, byte 6 Pressure control module, right front axle, excessive pressure during pulse test CAN data bus: EBS message EBC4, byte 7 CAN data bus driveline Pressure control module, right front axle, residual pressure after braking BUSOFF vehicle CAN CAN data bus: EBS message EBC4, byte 8 CAN data bus error warning Pressure control module, right front axle, pressure sensor fault without braking CAN data bus: EBS message Veh_weight, byte 1 CAN data bus input buffer overrun Pressure control module, right front axle, no valid fault definition CAN data bus: EBS message Veh_weight, bytes 2 and 3 CAN data bus electronic engine governor 1 from EDC, EEC1 Pressure control module, right front axle, wheel sensor IC defective Timeout of EEC1 message CAN data bus: EBS message Veh_weight, byte 4 CAN data bus electronic engine governor 2 from EDC, EEC2 Total exhaust-relevant errors (ASE) cylinder 1, damaging to catalytic converter Pressure control module, right front axle, faulty backup valve checkback CAN signal 'Position Of Doors' Timeout of EEC2 message CAN data bus: Retarder message RET_Conf, byte 1 CAN data bus cruise control/speed from EDC, CCVS Total exhaust-relevant errors (ASE) cylinder 2, damaging to catalytic converter Pressure control module, right front axle, faulty intake valve checkback Intake valve checkback (ABS valve front axle right) CAN signal 'Seconds' in 'Time/Date' message Timeout CcVeh speed message CAN data bus: Retarder message RET_Conf, byte 2 CAN data bus engine brake from vehicle management computer, ERC1_REX Total exhaust-relevant errors (ASE) cylinder 3, damaging to catalytic converter Pressure control module, right front axle, faulty intake and backup valve checkback CAN signal 'Minutes' in 'Time/Date' message CAN data bus: Retarder message RET_Conf, bytes 3 and 4 CAN data bus retarder from secondary retarder, ERC1_RD Total exhaust-relevant errors (ASE) cylinder 4, damaging to catalytic converter Pressure control module, right front axle, faulty outlet valve checkback Exhaust valve checkback (ABS valve front axle right) CAN signal 'Hours' in 'Time/Date' message CAN data bus: Retarder message RET_Conf, byte 5 CAN data bus primary retarder WSK, ERC1_RE Page 181 of 276

SPN

Control unit/System

03185

CNG_ME7

03185 03185 03185 03186

EBS EHLA FFR AST

03186

CNG_ME7

03186

EBS

03186 03186 03186 03187

EBS_K1 EHLA FFR AST

03187

CNG_ME7

03187 03187

EBS EHLA

03187 03188 03188

FFR AST CNG_ME7

03188 03188 03188 03189

EBS EHLA FFR AST

Pressure control module, right front axle, no valid fault definition CAN signal 'Engine Speed' CAN data bus: Retarder message RET_Conf, byte 11 Control unit fault, stack watch

03189 03189

EBS EHLA

Pressure control module, right front axle, no valid fault definition CAN signal 'Front Axle Speed'

03189 03190

FFR AST

03190 03190 03190 03191

EBS EHLA FFR AST

CAN data bus: Retarder message RET_Conf, bytes 12 and 13 EOL EEPROM parameter outside valid range Pressure control module, right front axle, no CAN reception from module CAN signal 'Tachograph Vehicle Speed' CAN data bus: Retarder message RET_Conf, byte 14 EOL EEPROM: checksum error

03191 03191

EBS EHLA

Pressure control module, right front axle, software incompatibility between control unit and pressure control module CAN signal 'Wheel_BasedVehicleSpeed'

03191 03192

FFR AST

03192 03192

EBS EHLA

03192 03193

FFR AST

03193 03193 03193 03193

EBS EHLA EMOS FFR

SD 812a en-online 05.2007

Fault message Total exhaust-relevant errors (ASE) cylinder 5, damaging to catalytic converter Pressure control module, right front axle, faulty outlet and backup valve checkback CAN signal 'Day' in 'Time/Date' message CAN data bus: Retarder message RET_Conf, bytes 6 and 7 CAN data bus primary retarder WSK, ERC1_WSK Total exhaust-relevant errors (ASE) cylinder 6, damaging to catalytic converter Pressure control module, right front axle, faulty outlet and intake valve checkback Exhaust and intake valve checkback (ABS valve front axle right) CAN signal 'Month' in 'Time/Date' message CAN data bus: Retarder message RET_Conf, byte 8 CAN data bus primary retarder configuration information Total exhaust-relevant errors (ASE), total, damaging to catalytic converter Pressure control module, right front axle, faulty outlet and intake and backup valve checkback CAN signal 'Year' in 'Time/Date' message CAN data bus: Retarder message RET_Conf, bytes 9 and 10 Control unit fault, incorrect interrupt Input parameters filling acquisition

CAN data bus: Retarder message RET_Conf, bytes 15 and 16 Control unit fault – EEPROM access fault Pressure control module, right front axle, 12/24 volt incompatibility between control unit and pressure control module CAN signal 'High Resolution Total Vehicle Distance' CAN data bus: Retarder message RET_Conf, bytes 17 and 18 ECU temperature too high Pressure control module, right front axle, high cycle protection intake valve active, pressure < 4 bar CAN signal 'Transmission Current Gear' Permitted temperature limit value exceeded CAN data bus: Retarder message RET_Conf, byte 19 Page 182 of 276

SPN 03194

Control unit/System AST

03194 03194 03194

EBS EHLA FFR

03195 03195 03195

EBS EHLA FFR

03196

AST

03196 03196 03196 03196

EBS EHLA EMOS FFR

03197 03197 03197

EBS EHLA FFR

03198

AST

03198 03198

EBS FFR

Fault message Failure of both signal sources for front axle speed Pressure control module, right front axle, arithmetic test not successful CAN signal 'ASR Engine Control Active Passive' CAN data bus: Retarder message ERC1_RD, byte 1 Pressure control module, right front axle, wheel compensation fault wheel sensor A CAN signal 'ASR Brake Control Active Passive' CAN data bus: Retarder message ERC1_RD, byte 2 CAN data bus vehicle mileage from central on-board computer ZBR2, Veh_Dist Pressure control module, right front axle, wheel compensation fault wheel sensor B CAN signal 'Anti-Lock Braking (ABS) Active' Timeout of Veh_Dist message CAN data bus: Retarder message ERC1_RD, byte 3 Pressure control module, right front axle, electrical power supply fault, axle load sensor CAN signal 'Reverse engaged' CAN data bus: Astronic message ETC1, byte 1 CAN data bus relative wheel speed from EBS, EBC2 (WSI) (relative wheel speed) Pressure control module, right front axle, pressure differential on pressure control module pair, front axle CAN data bus: Astronic message ETC1, bytes 2 and 3

03199

AST

CAN data bus wheel speed information from EBS, EBC2 (WSI)

03199 03199 03199 03200 03200 03200 03200

EBS EMOS FFR EBS ECAS_4X2 ECAS2_GBV FFR

03201 03201 03201 03201 03201 03201 03201 03201

EBS EBS_K1 ECAS_4X2 ECAS2_GBV EHLA FFR OBDU ZBR2

03202 03202 03202 03202 03202

EBS ECAS_4X2 ECAS2_GBV EHLA FFR

03203 03203 03203 03203 03203 03203

EBS ECAS_4X2 ECAS2_GBV EHLA FFR OBDU

03204 03204

EBS ECAS_4X2

Pressure control module, right front axle, no valid fault definition Timeout of EBC2 message CAN data bus: Astronic message ETC1, byte 4 Pressure control module, left rear axle, no fault Supply voltage / feedback, solenoid valves Supply voltage / feedback, solenoid valves CAN data bus: Astronic message ETC1, byte 5 Pressure control module, left rear axle, interruption, short-circuit wheel sensor A (!) Wheel sensor left rear axle Solenoid valve 2/2 left REAR AXLE Solenoid valve 2/2 FRONT AXLE left Valve output 1 CAN data bus: Astronic message ETC1, bytes 6 and 7 Charge air pressure Low pressure in air filter Pressure control module, left rear axle, wheel sensor A: Delay too long Solenoid valve 2/2 right REAR AXLE Solenoid valve 2/2 FRONT AXLE right Valve output 2 CAN data bus: Astronic message ETC1, byte 8 Pressure control module, left rear axle, wheel sensor A: Moving off fault Solenoid valve 2/2 FRONT AXLE Solenoid valve 2/2 CENTRE AXLE Valve output 3 CAN data bus: Astronic message ETC2, byte 1 Leak in oil pump overflow valve Pressure control module, left rear axle, wheel sensor A: Clearance too great Solenoid valve 3/3 lower/load lifting/trailing axle

SD 812a en-online 05.2007

Page 183 of 276

SPN 03204 03204 03204 03204

Control unit/System ECAS2_GBV EHLA FFR ZBRO

03205 03205 03205 03205 03205 03205

EBS ECAS_4X2 ECAS2_GBV EHLA FFR ZBRO

03206 03206 03206 03206 03206 03206

EBS ECAS_4X2 ECAS2_GBV EHLA FFR ZBRO

03207 03207 03207 03207 03207 03207 03207

EBS EBS_K1 ECAS_4X2 ECAS2_GBV EHLA FFR ZBRO

03208 03208 03208 03208 03208 03208 03209

EBS ECAS_4X2 ECAS2_GBV EHLA FFR ZBRO AST

03209 03209 03209 03209 03209 03209

EBS EBS_K1 ECAS_4X2 ECAS2_GBV FFR ZBRO

03210

AST

03210 03210 03210

EBS ECAS_4X2 EMOS

03210 03210

FFR OBDU

03211 03211

AST CNG_ME7

03211 03211

EBS EMOS

03211 03211 03211

FFR KSM OBDU

SD 812a en-online 05.2007

Fault message Solenoid valve 3/3 lower/load lifting/trailing axle Valve output 4 CAN data bus: Astronic message ETC2, bytes 2 and 3 EDC is active Pressure control module, left rear axle, perpetual control wheel sensor A Solenoid valve 3/3 lift/unload lifting/trailing axle Solenoid valve 3/3 lift/unload lifting/trailing axle Valve output 5 CAN data bus: Astronic message ETC2, byte 4 EDC brake lamp Pressure control module, left rear axle, long instability wheel sensor A Solenoid valve 3/2 reservoir Solenoid valve 3/2 reservoir Valve output 6 CAN data bus: Astronic message ETC2, byte 5 EDC overtravel relay Pressure control module, left rear axle, pulse ring fault wheel sensor A (!) Impulse wheel fault left rear axle Solenoid valve 3/3 lifting bellows Solenoid valve 3/3 lifting bellows Valve output 7 CAN data bus: Astronic message ETC2, byte 6 EDC malfunction Pressure control module, left rear axle, fault on lifting axle wheel sensor A Solenoid valve 2/2, 3rd AXLE RIGHT Solenoid valve 2/2, 3rd AXLE RIGHT Valve output 8 CAN data bus: Astronic message ETC2, byte 7 EDC malfunction Emergency off button pressed or ECU de-energised Pressure control module, left rear axle, no valid fault definition (!) Brake/impulse wheel/sensor combination left rear axle Solenoid valve 2/2, 3rd AXLE LEFT Solenoid valve 2/2, 3rd AXLE LEFT CAN data bus: Astronic message ETC2, byte 8 EDC ignition on CAN data bus tachograph from central on-board computer ZBR2, TCO1 Pressure control module, left rear axle, no valid fault definition Solenoid valve 2/2 FRONT AXLE Timeout of TCO1 message CAN data bus: Central on-board computer message TCO1, byte 1 Air filter vacuum CAN data bus gearbox check from vehicle management computer FFR, TC1_FT Knock sensor 2 Pressure control module, left rear axle, interruption, short-circuit wheel sensor B Timeout of TC1_FT message CAN data bus: Central on-board computer message TCO1, byte 2 Oil pressure. Engine oil pressure too low Page 184 of 276

SPN 03211 03211

Control unit/System TPM ZBRO

03212

AST

03212 03212 03212

EBS ECAS_4X2 ECAS2_GBV

03212 03212 03212

FFR OBDU TPM

03213

AST

03213

EBS

03213 03213

FFR TPM

03214

AST

03214

EBS

03214 03214 03214

FFR TPM ZBRO

03215

AST

03215

EBS

03215 03215

FFR ZBRO

03216 03216 03216

EBS ECAS_4X2 ECAS2_GBV

03216 03216

FFR ZBRO

03217 03217 03217

EBS ECAS_4X2 ECAS2_GBV

03217 03217

FFR ZBRO

03218

EBS

03218 03218

FFR ZBRO

03219

EBS

03219 03219 03220

FFR ZBRO CNG_ME7

SD 812a en-online 05.2007

Fault message Medium leakage from left outer tyre, axle 1 Engine oil pressure too low CAN data bus gearbox check from vehicle management computer FFR, TC1_FT (requested gear) Pressure control module, left rear axle, wheel sensor B: Delay too long Solenoid valve transverse throttle Solenoid valve transverse throttle CAN data bus: Central on-board computer message TCO1, byte 3 Oil pressure too high Medium leakage from left inner tyre, axle 1 CAN data bus gearbox check from vehicle management computer FFR, TC1_FT (requested range) Pressure control module, left rear axle, wheel sensor B: Moving off fault CAN data bus: Central on-board computer message TCO1, byte 4 Medium leakage from right inner tyre, axle 1 CAN data bus gearbox check from vehicle management computer FFR, TC1_FT (PTO request) Pressure control module, left rear axle, wheel sensor B: Clearance too great CAN data bus: Central on-board computer message TCO1, bytes 5 and 6 Medium leakage from right outer tyre, axle 1 FFR malfunction CAN data bus information from central on-board computer (aux_stat_zbr#1), timeout Pressure control module, left rear axle, perpetual control wheel sensor B CAN data bus: Central on-board computer message TCO1, bytes 7 and 8 FFR malfunction Pressure control module, left rear axle, long instability wheel sensor B Solenoid valve 3/3, lift/unload 2nd lifting/trailing axle Solenoid valve 3/3, lift/unload 2nd lifting/trailing axle CAN data bus: Central on-board computer message VEH_DIST, bytes 1 to 4 Accelerator pedal not pressed (T-CAN) Pressure control module, left rear axle, pulse ring fault wheel sensor B Solenoid valve 3/3, lower/load 2nd lifting/trailing axle Solenoid valve 3/3, lower/load 2nd lifting/trailing axle CAN data bus: Central on-board computer message VEH_DIST, bytes 5 to 8 Accelerator pedal pressed Pressure control module, left rear axle, fault on lifting axle wheel sensor B CAN data bus: Central on-board computer message TIME/DATE, byte 1 Accelerator pedal kickdown (T-CAN) Pressure control module, left rear axle, no valid fault definition CAN data bus: Central on-board computer message TIME/DATE, byte 2 Accelerator pedal position (0...250) Knock control zero test Page 185 of 276

SPN

Control unit/System

03220

EBS

03220 03220

EBS_K1 EHLA

03220 03220 03221

FFR ZBRO CNG_ME7

03221 03221 03221

EBS EBS_K1 EHLA

03221 03221 03221 03222

FFR TPM ZBRO CNG_ME7

03222 03222 03222

EBS EBS_K1 EHLA

03222 03222 03222

FFR TPM ZBRO

03223

EBS

03223 03223

EBS_K1 EHLA

03223 03223 03223

FFR TPM ZBRO

03224 03224

EBS EHLA

03224 03224 03224 03225 03225 03225 03225 03225

FFR TPM ZBRO CNG_ME7 EBS EHLA FFR ZBRO

03226 03226 03226 03227

EBS FFR ZBRO AST

03227 03227 03227

EBS FFR ZBRO

03228 03228 03228

EBS FFR ZBRO

SD 812a en-online 05.2007

Fault message Pressure control module, left rear axle, electrical power supply fault, pad wear sensor Electrical power supply pad wear sensor (rear axle left or rear axle) CAN message 'Door_Ctrl' CAN data bus: Central on-board computer message TIME/DATE, byte 3 Cooling water level too low Knock control offset Pressure control module, left rear axle, pad wear sensor A outside permitted value range Pad wear sensor A (rear axle left) outside valid range CAN message 'Time_Date' CAN data bus: Central on-board computer message TIME/DATE, byte 4 Medium leakage from left outer tyre, axle 2 Cooling water level probe supply Knock control test pulse Pressure control module, left rear axle, pad wear sensor B outside permitted value range Pad wear sensor B (rear axle left) outside valid range CAN message 'High Resolution Vehicle Distance' CAN data bus: Central on-board computer message TIME/DATE, byte 6 Medium leakage from left inner tyre, axle 2 Cooling water temperature too high Pressure control module, left rear axle, pressure sensor outside permitted value range (!) Pressure sensor (left rear axle or rear axle) outside valid range CAN message 'ETC2' CAN data bus: Central on-board computer message TIME/DATE, byte 6 Medium leakage from right inner tyre, axle 2 Cooling water temperature Pressure control module, left rear axle, time for 'Current pressure' inquiry too long CAN message 'EBC1' CAN data bus: Central on-board computer message TIME/DATE, bytes 7 and 8 Medium leakage from right outer tyre, axle 2 Cooling water temperature too high Requirement adaptation at stop Pressure control module, left rear axle, poor ventilation CAN message 'AUX_STAT_ZBR1' CAN data bus: Retarder message RE_FLUIDS, byte 2 Motronic (accelerator) malfunction Pressure control module, left rear axle, excessive pressure during pulse test CAN data bus: Retarder message RE_FLUIDS, byte 2 Motronic (accelerator) malfunction Data field for CAN communication Pressure control module, left rear axle, residual pressure after braking CAN data bus: Retarder message RE_FLUIDS, byte 3 Engine oil pressure too low Pressure control module, left rear axle, pressure sensor fault without braking CAN data bus: Retarder message RD_FLUIDS, byte 2 Engine oil pressure Page 186 of 276

SPN

Control unit/System

03229 03229

EBS FFR

03230 03230 03230 03230 03230 03231

EBS ECAS_4X2 ECAS2_GBV EHLA FFR CNG_ME7

03231 03231 03231 03231 03231 03231 03231 03231

EBS EBS_K1 ECAS_4X2 ECAS2_GBV EHLA FFR TPM ZBRO

03232

EBS

03232 03232 03232 03232

EHLA FFR TPM ZBRO

03233 03233 03233 03233 03233

EBS EHLA FFR TPM ZBRO

03234 03234 03234 03234

EBS FFR TPM ZBRO

03235 03235 03235

EBS FFR ZBRO

03236

EBS

03236 03236 03236

EBS_K1 FFR ZBRO

03237 03237 03237

EBS FFR ZBRO

Exhaust and intake valve checkback (rear axle left or rear axle) CAN data bus: EBS message TSC1_AE, bytes 2 and 3 DeltecCNG malfunction Pressure control module, left rear axle, faulty outlet and intake and backup valve checkback CAN data bus: EBS message TSC1_AE, byte 4 EMS3.3 malfunction

03238 03238 03238 03238

EBS EHLA FFR ZBRO

Pressure control module, left rear axle, no valid fault definition Air pressure switch CAN data bus: EBS message TSC1_AE, byte 5 EMS3.3 malfunction

03239 03239

EBS EHLA

Pressure control module, left rear axle, no valid fault definition Actuator test when vehicle moving cancelled

SD 812a en-online 05.2007

Fault message Pressure control module, left rear axle, no valid fault definition CAN data bus: Retarder message RD_FLUIDS, byte 2 Pressure control module, left rear axle, wheel sensor IC defective Setpoint level control Setpoint level control Signature ECU lids (LID 0x86-0x9F) - advance warning CAN data bus: Retarder message RD_FLUIDS, byte 3 Charge air pressure governing system Pressure control module, left rear axle, faulty backup valve checkback Backup valve checkback (rear axle left or rear axle) Leakage Leakage Signature ECU lids (LID 0x86-0x9F) - error CAN data bus: Astronic message TSC1_TE, byte 1 Medium leakage from left outer tyre, axle 3 Oil replenishment float switch Pressure control module, left rear axle, faulty intake valve checkback Signature variable priority lids (LID 0x40-0x47) - advance warning CAN data bus: Astronic message TSC1_TE, bytes 2 and 3 Medium leakage from left inner tyre, axle 3 Oil replenishment valve Pressure control module, left rear axle, faulty intake and backup valve checkback Signature variable priority lids (LID 0x40-0x47) - error CAN data bus: Astronic message TSC1_TE, byte 4 Medium leakage from right inner tyre, axle 3 Engine oil level (T-CAN) Pressure control module, left rear axle, faulty outlet valve checkback CAN data bus: Astronic message TSC1_TE, byte 5 Medium leakage from right outer tyre, axle 3 Economy circ. headl. (oil pressure+v 0 Pressure control module, right rear axle, pad wear sensor B outside permitted value range Pad wear sensor B (rear axle right) outside valid range Function computer, monitoring modules CAN message 'Start engine' although input gearbox neutral open Pressure control module, right rear axle, pressure sensor outside permitted value range Function computer, monitoring modules CAN message 'Stop engine' although still v > 0 Pressure control module, right rear axle, time for 'Current pressure' inquiry too long

SD 812a en-online 05.2007

Page 190 of 276

SPN 03274

Control unit/System EHLA

03274 03275 03275

FFR EBS EHLA

03276 03276

EBS EHLA

03277 03277 03277

EBS EHLA FFR

03278 03278 03278

EBS EHLA FFR

03279 03279 03279

EBS EHLA FFR

03280 03280 03280

EBS EHLA FFR

03281 03281 03281

EBS EHLA FFR

03282 03282

EBS EHLA

03283 03283 03283

EBS EHLA FFR

03284 03284

EBS EHLA

03284

FFR

03285 03285 03285

EBS EHLA FFR

03286 03286 03286

EBS EHLA FFR

03287

EBS

Pressure control module, right rear axle, no valid fault definition Function computer, safety switch No speed signal (torque and engine speed limiting initiated) Pressure control module, right rear axle, wheel sensor IC defective Function computer, monitoring modules Vehicle management computer cannot be switched off Pressure control module, right rear axle, faulty backup valve checkback Function computer: Digital output 1, switch-on test Input request single H lever (group change switch) Pressure control module, right rear axle, faulty intake valve checkback Function computer, digital outputs 2 – 6, switch-on test Pressure control module, right rear axle, faulty intake and backup valve checkback Function computer, digital outputs 2 – 6, switch-on test Gate switch gearbox Pressure control module, right rear axle, faulty outlet valve checkback Function computer, digital outputs 2 – 6, switch-on test Shifting in split gears not completed (no change or no powerflow) or clutch slip detected Pressure control module, right rear axle, faulty outlet and backup valve checkback Function computer, digital outputs 2 – 6, switch-on test Check clutch for wear Pressure control module, right rear axle, faulty outlet and intake valve checkback Function computer, digital outputs 2 – 6, switch-on test Brake pedal switch Pressure control module, right rear axle, faulty outlet and intake and backup valve checkback

03287

FFR

CAN data bus: Time overrun when receiving VSM message TCI

03288

EBS

Pressure control module, right rear axle, no valid fault definition

03289

EBS

03290 03290

EBS FFR

Pressure control module, right rear axle, no valid fault definition Pressure control module, right rear axle, no CAN reception from module Control unit (register test)

SD 812a en-online 05.2007

Fault message Function computer, monitoring modules Gearbox input speed to gearbox output speed with gearbox in neutral Pressure control module, right rear axle, poor ventilation Function computer, monitoring modules Pressure control module, right rear axle, excessive pressure during pulse test Function computer, monitoring modules Pressure control module, right rear axle, residual pressure after braking Function computer, monitoring modules No engine CAN Pressure control module, right rear axle, pressure sensor fault without braking Function computer, monitoring modules Input speed

Page 191 of 276

SPN

Control unit/System

03291 03291

EBS FFR

03292 03292

EBS FFR

03293 03293

EBS FFR

03294 03294

EBS FFR

03295 03295

EBS FFR

03296 03296

EBS FFR

03297 03297

EBS FFR

03298 03298 03299

EBS FFR CNG_ME7

03299 03300 03300 03300 03300 03300

EBS EBS FFR OBDU ZBR2 ZBRO

03301 03301 03301 03301 03301 03302 03302 03302 03303 03303 03303 03303

EBS EBS_K1 FFR OBDU ZBR2 EBS FFR ZBR2 EBS FFR ZBR2 ZBRO

03304 03304 03304

EBS FFR OBDU

03305 03305 03306 03306

EBS FFR EBS FFR

03306 03307 03307

OBDU EBS EBS_K1

SD 812a en-online 05.2007

Fault message Pressure control module, right rear axle, software incompatibility between control unit and pressure control module Control unit (arithmetic) Pressure control module, right rear axle, 12/24 volt incompatibility between control unit and pressure control module Control unit (RAM) Pressure control module, right rear axle, high cycle protection intake valve active, pressure < 4 bar Control unit (watchdog) Pressure control module, right rear axle, arithmetic test not successful Control unit (watchdog has tripped) Pressure control module, right rear axle, wheel compensation fault wheel sensor A Control unit (RAM page) Pressure control module, right rear axle, wheel compensation fault wheel sensor B Control unit (RAM/ROM segment) Pressure control module, right rear axle, electrical power supply fault, axle load sensor Control unit (page error ROM) Pressure control module, right rear axle, pressure differential on pressure control module pair, rear axle Control unit (checksum ROM) Pressure sensor surroundings Pressure control module, right rear axle, no valid fault definition Pressure control module E, no fault Control unit or cable line (engine brake output stage) Alternator speed Alternator / starter Engine revs Pressure control module E, interruption, short-circuit wheel sensor A (!) Wheel sensor left auxiliary axle Control unit or peripherals (output stage, clutch servo) Engine oil temperature too high Alternator tl. L Pressure control module E, wheel sensor A: Delay too long Control unit or cable line (power take-off 1 output stage) Alternator B+ sense Pressure control module E, wheel sensor A: Moving off fault Control unit or cable line (power take-off 2 output stage) Engine running (= signal D+) Engine running Pressure control module E, wheel sensor A: Clearance too great Control unit or cable line (thermostat heater output stage) EDC boiling protection Pressure control module E, perpetual control wheel sensor A Control unit or cable line (high range output stage) Pressure control module E, long instability wheel sensor A Control unit or cable line (low range output stage) Thermostat in cooling system defective or too much heat being taken (heater) Pressure control module E, pulse ring fault wheel sensor A (!) Impulse wheel fault left additional axle Page 192 of 276

SPN

Control unit/System

03308 03308 03309

EBS FFR EBS

Pressure control module E, fault on lifting axle wheel sensor A Control unit or cable line (earth group output stage) Pressure control module E, no valid fault definition

03309 03309 03310 03310

EBS_K1 FFR EBS FFR

03311 03311 03311 03311 03311 03312 03312 03313 03313 03313

EBS FFR KSM OBDU TPM EBS TPM EBS TPM ZBRO

(!) Brake/impulse wheel/sensor combination left additional axle Control unit or cable line (earth splitter output stage) Pressure control module E, no valid fault definition Ride height Pressure control module E, interruption, short-circuit wheel sensor B Control unit (EEPROM checksum) Cooling water temperature. Cooling water temperature too high Severe leakage from left outer tyre, axle 1 Pressure control module E, wheel sensor B: Delay too long Severe leakage from left inner tyre, axle 1 Pressure control module E, wheel sensor B: Moving off fault Severe leakage from right inner tyre, axle 1 Econ. circ. heat./airc. (altern. running)

03314 03314 03314

EBS TPM ZBRO

Pressure control module E, wheel sensor B: Clearance too great Severe leakage from right outer tyre, axle 1 Economy circuit workshop jumper

03315 03315 03316 03316 03317 03317

EBS ZBRO EBS ZBRO EBS ZBRO

Pressure control module E, perpetual control wheel sensor B Charge check alternator LIMA1 Pressure control module E, long instability wheel sensor B Starter start interlock repeat rel. Pressure control module E, pulse ring fault wheel sensor B Roller-type sw. 1 start interr. (open)

03318 03318 03319 03319 03319

EBS ZBRO CNG_ME7 EBS ZBRO

03320

EBS

03320 03320

EBS_K1 ZBRO

03321 03321 03321 03321 03322

EBS EBS_K1 TPM ZBRO CNG_ME7

03322 03322 03322 03322

EBS EBS_K1 TPM ZBRO

03323

EBS

03323 03323 03323

EBS_K1 TPM ZBRO

SD 812a en-online 05.2007

Fault message

Pressure control module E, fault on lifting axle wheel sensor B Roller-type sw. 2 start interr. (closed) Throttle butterfly actuator minimum stop Pressure control module E, no valid fault definition Alternator LIMA1 not charging Pressure control module E, electrical power supply fault, pad wear sensor Electrical power supply pad wear sensor (additional axle left or additional axle) Charge check alternator LIMA2 Pressure control module E, pad wear sensor A outside permitted value range Pad wear sensor A additional axle left outside valid range Severe leakage from left outer tyre, axle 2 Alternator LIMA2 not charging Crankshaft to camshaft signal Pressure control module E, pad wear sensor B outside permitted value range Pad wear sensor B additional axle left outside valid range Severe leakage from left inner tyre, axle 2 Engine start in rear Pressure control module E, pressure sensor outside permitted value range (!) Pressure sensor (left additional axle or additional axle) outside valid range Severe leakage from right inner tyre, axle 2 Engine stop in rear Page 193 of 276

SPN

Control unit/System

03324 03324 03324 03325 03325 03325

EBS TPM ZBRO CNG_ME7 EBS ZBRO

03326 03326 03327 03327

EBS ZBRO EBS ZBRO

03328 03328 03329 03329 03329 03330 03330 03331 03331 03331 03332 03332 03332

EBS ZBRO CNG_ME7 EBS ZBRO EBS ZBRO EBS TPM ZBRO EBS TPM ZBRO

03333 03333 03333 03334 03334 03334

EBS TPM ZBRO EBS TPM ZBRO

03335 03335

EBS ZBR2

03336

EBS

03336 03336

EBS_K1 ZBRO

03337 03337 03338 03338 03339 03339 03340 03340

EBS ZBRO EBS ZBRO EBS ZBRO EBS ZBRO

03341

EBS

03341 03341 03341

EBS_K1 TPM ZBRO

03342 03342 03342

EBS TPM ZBRO

SD 812a en-online 05.2007

Fault message Pressure control module E, time for 'Current pressure' inquiry too long Severe leakage from right outer tyre, axle 2 Roller-type sw. start interr. fault Crankshaft to camshaft signal (bank 2) Pressure control module E, poor ventilation Fuel tank flap (start interlock/eng. stop) Pressure control module E, excessive pressure during pulse test Engine compartment flap open Pressure control module E, residual pressure after braking Gearb. n. neutral (starting impossible) Pressure control module E, pressure sensor fault without braking Start interruption via fuel tank flap Suction pipe pressure sensor Pressure control module E, no valid fault definition Engine start front Pressure control module E, wheel sensor IC defective Engine stop front Pressure control module E, faulty backup valve checkback Severe leakage from left outer tyre, axle 3 Roller-type sw. 3 start interr. (open) Pressure control module E, faulty intake valve checkback Severe leakage from left inner tyre, axle 3 Roller-type sw. 4 start interr. (closed) Pressure control module E, faulty intake and backup valve checkback Severe leakage from right inner tyre, axle 3 Central front flap open Pressure control module E, faulty outlet valve checkback Severe leakage from right outer tyre, axle 3 Roller-type sw. start interr. fault fr. Pressure control module E, faulty outlet and backup valve checkback Voltage specification not possible (alternator / starter) Pressure control module E, faulty outlet and intake valve checkback Exhaust and intake valve checkback (additional axle left or additional axle) Supply compartment open Pressure control module E, faulty outlet and intake and backup valve checkback Roller-type sw. start interr. fault fr. Pressure control module E, no valid fault definition Start interrupted Pressure control module E, no valid fault definition Flap 1 left open Pressure control module E, no CAN reception from module Flap 2 left open Pressure control module E, software incompatibility between control unit and pressure control module Software statuses of control unit and pressure-control module (additional axle left or additional axle) do not match Severe leakage from left outer tyre, axle 4 Flap 2 right open Pressure control module E, 12/24 volt incompatibility between control unit and pressure control module Severe leakage from left inner tyre, axle 4 Flap 3 left open Page 194 of 276

SPN

Control unit/System

03343 03343 03343 03344

EBS TPM ZBRO EBS

03344 03344 03344

EBS_K1 TPM ZBRO

03345 03345

EBS ZBRO

03346 03346

EBS ZBRO

03347 03347

EBS ZBR2

03348 03349 03350

EBS EBS EBS

03351 03351 03351 03352 03352 03353 03353 03353

EBS EBS_K1 TPM EBS TPM CNG_ME7 EBS TPM

03354 03354 03355 03355

EBS TPM EBS TPM

03356 03356

CNG_ME7 EBS

Lambda control adaptation multiplicative lower range (bank 1) Pressure control module F, long instability wheel sensor A

03357 03357 03357

CNG_ME7 EBS EBS_K1

Lambda control adaptation multiplicative upper range (bank 1) Pressure control module F, pulse ring fault wheel sensor A (!) Impulse wheel fault right additional axle

03358 03359

EBS EBS

Pressure control module F, fault on lifting axle wheel sensor A Pressure control module F, no valid fault definition

03359 03360 03360

EBS_K1 CNG_ME7 EBS

03361 03361 03362 03362 03362 03363 03363

EBS EHLA CNG_ME7 EBS EHLA EBS EHLA

(!) Brake/impulse wheel/sensor combination right additional axle Lambda control adaptation leakage air (bank 1) Pressure control module F, no valid fault definition Pressure control module F, interruption, short-circuit wheel sensor B Function computer, monitoring modules Lambda control adaptation fuel (bank 1) Pressure control module F, wheel sensor B: Delay too long Function computer, monitoring modules Pressure control module F, wheel sensor B: Moving off fault Function computer, monitoring modules

03364

EBS

Pressure control module F, wheel sensor B: Clearance too great

SD 812a en-online 05.2007

Fault message Pressure control module E, high cycle protection intake valve active, pressure < 4 bar Severe leakage from right inner tyre, axle 4 Flap 4 left open Pressure control module E, arithmetic test not successful Pressure-control module (additional axle left or additional axle) defective, arithmetic test unsuccessful Severe leakage from right outer tyre, axle 4 Battery flap open Pressure control module E, wheel compensation fault wheel sensor A Flap in rear flap open Pressure control module E, wheel compensation fault wheel sensor B Engine stop in rear Pressure control module E, electrical power supply fault, axle load sensor Terminal L alternator 2 Pressure control module E, pressure differential on pressure control module pair, rear axle Pressure control module E, no valid fault definition Pressure control module F, no fault Pressure control module F, interruption, short-circuit wheel sensor A (!) Wheel sensor right additional axle Severe leakage from left outer tyre, axle 5 Pressure control module F, wheel sensor A: Delay too long Severe leakage from left inner tyre, axle 5 Pressure sensor charge air pressure Pressure control module F, wheel sensor A: Moving off fault Severe leakage from right inner tyre, axle 5 Pressure control module F, wheel sensor A: Clearance too great Severe leakage from right outer tyre, axle 5 Pressure control module F, perpetual control wheel sensor A LID checksum error

Page 195 of 276

SPN 03364 03365 03365 03366 03366 03367 03367

Control unit/System EHLA EBS EHLA EBS EHLA EBS EHLA

03368 03368 03369 03369

EBS EHLA EBS EHLA

03370 03370

EBS EHLA

03371 03371 03371

EBS EBS_K1 EHLA

03372 03372 03372

EBS EBS_K1 EHLA

03373 03373

EBS EHLA

03374 03374 03375 03375

EBS EHLA EBS EHLA

03376 03376 03377

EBS EHLA EBS

03378 03379 03380 03381 03381 03382 03382 03382

EBS EBS EBS EBS EHLA CNG_ME7 EBS EHLA

03383 03383 03384 03384

EBS EHLA EBS EHLA

03385 03385

EBS EHLA

03386 03386

EBS EHLA

03387 03388 03389 03390

EBS EBS EBS EBS

SD 812a en-online 05.2007

Fault message Function computer, monitoring modules Pressure control module F, perpetual control wheel sensor B Function computer, monitoring modules Pressure control module F, long instability wheel sensor B Function computer, overvoltage Pressure control module F, pulse ring fault wheel sensor B Function computer, undervoltage Pressure control module F, fault on lifting axle wheel sensor B Function computer, overtemperature Pressure control module F, no valid fault definition Function computer, monitoring modules Pressure control module F, electrical power supply fault, pad wear sensor Function computer, monitoring modules Pressure control module F, pad wear sensor A outside permitted value range Pad wear sensor A (additional axle right) outside valid range Function computer, monitoring modules Pressure control module F, pad wear sensor B outside permitted value range Pad wear sensor B (additional axle right) outside valid range Function computer, monitoring modules Pressure control module F, pressure sensor outside permitted value range Function computer, monitoring modules Pressure control module F, time for 'Current pressure' inquiry too long Function computer, output voltage '5V ref' Pressure control module F, poor ventilation Function computer, output voltage '5V ext' Pressure control module F, excessive pressure during pulse test Function computer, monitoring modules Pressure control module F, residual pressure after braking Pressure control module F, pressure sensor fault without braking Pressure control module F, no valid fault definition Pressure control module F, wheel sensor IC defective Pressure control module F, faulty backup valve checkback Function computer, digital output 1 Circuit trailing throttle circulating air valve Pressure control module F, faulty intake valve checkback Function computer, digital outputs 2 – 6, operation Pressure control module F, faulty intake and backup valve checkback Function computer, digital outputs 2 – 6, operation Pressure control module F, faulty outlet valve checkback Function computer, digital outputs 2 – 6, operation Pressure control module F, faulty outlet and backup valve checkback Function computer, digital outputs 2 – 6, operation Pressure control module F, faulty outlet and intake valve checkback Function computer, digital outputs 2 – 6, operation Pressure control module F, faulty outlet and intake and backup valve checkback Pressure control module F, no valid fault definition Pressure control module F, no valid fault definition Pressure control module F, no CAN reception from module Page 196 of 276

SPN

Control unit/System

03391

EBS

03392

EBS

03393 03394

EBS EBS

03395

EBS

03396

EBS

03397

EBS

03398 03399 03400 03400

EBS EBS EBS ZBR2

03401 03401 03401 03402 03402 03402 03402 03403

EBS OBDU ZBR2 CNG_ME7 EBS OBDU ZBR2 CNG_ME7

03403 03403 03403 03404

EBS OBDU ZBR2 CNG_ME7

03404 03404 03405

EBS OBDU CNG_ME7

03405 03406

EBS CNG_ME7

03406 03407 03407 03407 03408

EBS CNG_ME7 EBS OBDU CNG_ME7

03408 03408 03409

EBS OBDU CNG_ME7

03409 03410 03410 03410 03411 03411 03411 03412 03412

EBS CNG_ME7 EBS OBDU CNG_ME7 EBS FFR CNG_ME7 EBS

SD 812a en-online 05.2007

Fault message Pressure control module F, software incompatibility between control unit and pressure control module Pressure control module F, 12/24 volt incompatibility between control unit and pressure control module Pressure control module F, high cycle protection intake valve active, pressure < 4 bar Pressure control module F, arithmetic test not successful Pressure control module F, wheel compensation fault wheel sensor A Pressure control module F, wheel compensation fault wheel sensor B Pressure control module F, electrical power supply fault, axle load sensor Pressure control module F, pressure differential on pressure control module pair, rear axle Pressure control module F, no valid fault definition Trailer control module, no fault Flame start solenoid valve Trailer control module control electronics, unknown µC interrupt, µC self-test, RAM or ROM test Engine oil level too high/low (static) Flame start relay Throttle butterfly position deviation Trailer control module, no valid fault definition Engine oil level too high (dynamic) Flame glow plug current Throttle butterfly output stage switched off Trailer control module control electronics, EEPROM, too many write accesses Engine oil level too low (dynamic) Flame glow plug current Throttle butterfly controller in limit Trailer control module control electronics, EEPROM, checksum fault or EOL data invalid Cooling water level too low Monitoring computer; ROM Trailer control module control electronics, EEPROM, too many data repairs required Monitoring computer; RAM Trailer control module control electronics, EEPROM, monitoring time exceeded when writing data Monitoring computer; reset Trailer control module, no valid fault definition Oil level in power steering 1 too low Monitoring function; torque comparison Trailer control module control electronics, EEPROM, fault in dynamic parameter setting Oil level in power steering 2 too low Monitoring function; safety fuel shut-off Trailer control module control electronics, EEPROM, dynamic parameters outside permitted value range Throttle butterfly error when checking limp-home air position Trailer control module, no valid fault definition Clutch oil level too low Throttle butterfly error in booster balancing Trailer control module, no valid fault definition Gearbox output speed out of permitted range Throttle butterfly error in spring check 'Closing' Trailer control module, no valid fault definition Page 197 of 276

SPN

Control unit/System

03412 03413 03413

FFR CNG_ME7 EBS

03413 03414 03414 03415

FFR EBS FFR EBS

03415 03416

FFR EBS

03416 03417

FFR EBS

03417 03418 03419 03420 03421 03421 03421

FFR EBS EBS EBS EBS EBS_K1 EHLA

03422

EBS

03422 03422

EBS_K1 EHLA

03423 03423 03424 03424

EBS EHLA EBS EHLA

03425

EBS

03426 03427 03428 03429 03430 03430 03430 03430 03431 03431 03431 03432 03432 03433 03433 03433 03434 03434 03434 03435 03435 03435

EBS EBS EBS EBS CNG_ME7 EBS EBS_K1 FFR CNG_ME7 EBS FFR EBS FFR EBS EBS_K1 FFR EBS EBS_K1 FFR EBS EBS_K1 FFR

SD 812a en-online 05.2007

Fault message Range-change neutral switch indicates 'Neutral' - Power take-off neutral switch indicates 'Not Neutral' Throttle butterfly learning error when ignition on/off Trailer control module, no valid fault definition Range-change neutral switch indicates 'Not Neutral' - Power take-off neutral switch indicates 'Neutral' Trailer control module, no valid fault definition Output stage lamp FGB (driving speed limiter) Trailer control module, no valid fault definition CAN data bus, oil sensor message: Temperature rise not plausible although engine is warm (> 60 °C) Trailer control module, fault in coupling force control CAN data bus, oil sensor message: Oil level drop not plausible although engine is running Trailer control module, no valid fault definition Range-change neutral switch indicates 'Not Neutral' - Power take-off neutral switch indicates 'Neutral' Trailer control module, no valid fault definition Trailer control module, fault in earth estimation Trailer control module, no valid fault definition Trailer control module, no valid fault definition Pressure sensor supply trailer control valve Function computer, digital input 1 Trailer control module, pressure sensor outside permitted value range (!) Pressure sensor supply trailer control valve outside the permitted range Function computer, digital input 2 Trailer control module, implausible pressure sensor value when braking was not taking place Function computer, digital input 3 Trailer control module, no valid fault definition Function computer, digital input 4 Trailer control module, pressure dissipation too slow and fault on parking brake switch Trailer control module, residual pressure after pressure dissipation greater than threshold value on parking brake switch Trailer control module, residual pressure after braking Trailer control module, no valid fault definition Trailer control module, no valid fault definition Throttle butterfly potentiometer 1 Trailer control module, no valid fault definition Trailer control valve; solenoid valve CAN databus: Timeout when receiving KSM message KSM1 Throttle butterfly potentiometer 2 Trailer control module, faulty backup valve checkback CAN databus: KSM message KSM1, bytes 2 and 3 Trailer control module, faulty intake valve checkback CAN databus: KSM message KSM1, byte 4 Trailer control module, no valid fault definition Trailer control valve; solenoid valve feed line CAN databus: KSM message KSM1, byte 5 Trailer control module, faulty outlet valve checkback Trailer control valve; solenoid valve return line CAN databus: KSM message KSM1, byte 8 Trailer control module, no valid fault definition Trailer control valve; solenoid valve return line Engine start requested although vehicle speed > 0 km/h Page 198 of 276

SPN

Control unit/System

03436

EBS

03436 03437 03437 03438 03439

FFR EBS FFR EBS EBS

03440

EBS

03441

EBS

03442

EBS

03443 03444

EBS EBS

03445 03446 03447

EBS EBS EBS

03448 03449

EBS EBS

03449 03450 03450 03451 03452 03453 03454 03455 03456 03457

FFR EBS FFR EBS EBS EBS EBS EBS EBS EBS

03457 03457 03458 03458 03459 03459 03460

FFR HDS EBS FFR EBS FFR EBS

03460

FFR

03461 03461 03461 03462 03462 03462 03463 03463 03463 03464 03464 03464 03465 03465

EBS EHLA FFR EBS EHLA FFR EBS EHLA FFR EBS EHLA FFR EBS FFR

SD 812a en-online 05.2007

Fault message Trailer control module, fault from outlet and intake valve checkback Engine start requested although gearbox not in neutral position Trailer control module, no valid fault definition Engine start requested although vehicle speed > 0 km/h Trailer control module, no valid fault definition Trailer control module, no valid fault definition Trailer control module, no CAN reception from trailer control module Trailer control module, software incompatibility between control unit and trailer control module Trailer control module, 12/24 volt incompatibility between control unit and trailer control module Trailer control module, high cycle protection intake valve active, pressure < 4 bar Trailer control module, arithmetic test not successful Trailer control module, impermissible pressure on coupling head Trailer control module, no valid fault definition Trailer control module, no valid fault definition Trailer control module, pressure differential between pressure control modules and trailer control module Trailer control module, no valid fault definition Exhaust backpressure is measured although the exhaust valve brake control valve is not activated ESP, no valid error definition Exhaust backpressure (plausibility pressure - valve control) ESP, internal control unit error ESP, no valid error definition ESP, checkback, voltage implausible ESP, no valid error definition ESP configuration not valid ESP, EEPROM, checksum invalid ESP, EEPROM, parameter defective CAN data bus: Time overrun when receiving ACC message TSC1-ACC. AdBlue tank fill level (tank empty) ESP, EEPROM, parameter out-of-range CAN data bus: ACC message TSC1-ACC, bytes 1 and 2 ESP, EEPROM, not programmable CAN data bus: ACC message TSC1-ACC, bytes 4 and 5 ESP, no valid error definition CAN data bus: Time overrun when receiving ACC message ACC1. ESP EOL data in the EBS ECU not compatible with ESP software version Function computer, analog inputs 1 – 4, operation CAN data bus: ACC message ACC1, byte 4 ESP, no valid error definition Function computer, analog inputs 1 – 4, operation CAN data bus: Time overrun of gearbox message TSC1-TRX ESP, no valid error definition Function computer, analog inputs 1 – 4, operation DNR switch: No neutral position found ESP, no valid error definition Function computer, analog inputs 1 – 4, operation DNR switch: No neutral position found ESP, no valid error definition Time overrun when receiving EBS message TSC1_ARFFR Page 199 of 276

SPN 03466 03466 03467 03467 03468 03468 03469 03469 03470 03470

Control unit/System EBS FFR EBS FFR EBS FFR EBS FFR EBS FFR

03471 03471

EBS FFR

03472 03472 03473 03473

EBS FFR EBS EBS_5

Fault message ESP, no valid error definition CAN databus: EBS message TSC1_ARFFR, byte 4 (torque) ESP, lateral acceleration sensor out of permitted range CAN databus: Time overrun message EEC1-CM570 ESP, no valid error definition CAN databus: Time overrun message EEC2-CM570 ESP, lateral acceleration sensor, long-time alignment CAN databus: Time overrun message EEC3-CM570 ESP, lateral acceleration sensor, standstill alignment CAN databus: Time overrun message ERC1_RE-CM570 ESP, lateral acceleration sensor, plausibility monitoring valid for model CAN databus: Time overrun message ENG_TEMP-M570 ESP, lateral acceleration sensor, plausibility monitoring not valid for model CAN databus: Time overrun message FUEL_ECO-CM570 ESP, steering angle sensor not calibrated ESP, steering angle sensor not calibrated

03473 03474

FFR EBS

CAN databus: Time overrun message INL_EXH_COND_CM570 ESP, steering angle sensor, CAN timeout

03474 03475 03475

FFR EBS FFR

CAN databus: Time overrun message ENG_FL_LV_PR_CM570 ESP, steering angle sensor out of permitted range CAN data bus: Message ECAM1, byte 2

03476 03476 03477 03477 03478 03478 03479 03479

EBS FFR EBS FFR EBS FFR EBS FFR

03480 03480

EBS FFR

03481 03482 03483 03484

EBS EBS EBS EBS

ESP, steering angle sensor, defective CAN message content CAN data bus: Message ECAM1, byte 3 ESP, steering angle sensor, gradient error CAN data bus: Message ECAM1, byte 4 ESP, steering angle sensor, long-time alignment CAN databus: Time overrun message KSM2 ESP, steering angle sensor, constant signal CAN databus: Time overrun message ASC1_A ESP, steering angle sensor incorrectly mounted, incorrect steering angle sign CAN databus: Time overrun message ASC1_B ESP, steering angle sensor, plausibility monitoring between steering angle and rotational speed ESP, no valid error definition ESP, rotational speed sensor, CAN timeout ESP, rotational speed sensor signal out of permitted range

03485 03486 03487 03488 03489 03490 03491 03492 03493

EBS EBS EBS EBS EBS EBS EBS EBS EBS

03494

EBS

03495

EBS

03496

EBS

03497

EBS

SD 812a en-online 05.2007

ESP, rotational speed sensor, defective CAN message content ESP, rotational speed sensor, static BITE error ESP, rotational speed sensor, dynamic BITE error ESP, steering angle sensor, gradient error ESP, no valid error definition ESP, rotational speed sensor, fast alignment ESP, rotational speed sensor, standstill alignment ESP, rotational speed sensor, normal alignment ESP, rotational speed sensor, sensitivity error ESP, rotational speed sensor, plausibility monitoring valid for model ESP, rotational speed sensor, plausibility monitoring not valid for model ESP, rotational speed sensor incorrectly mounted, incorrect steering angle sign ESP, rotational speed sensor, plausibility monitoring between rotational speed and steering angle Page 200 of 276

SPN 03498 03499 03500 03500 03500 03500 03501 03501 03501 03501 03502 03502 03502 03502 03502 03503 03503 03503 03503 03503 03504

Control unit/System EBS EBS EBS FFR KSM ZBR2 EBS FFR OBDU ZBR2 EBS FFR OBDU ZBR2 ZBRO EBS FFR OBDU ZBR2 ZBRO EBS

03504 03504 03505 03505 03505 03506 03506

FFR OBDU EBS FFR OBDU EBS FFR

03506 03506 03507 03507 03508 03508 03509 03509 03510 03510 03510 03511 03511 03511 03512 03512 03512 03512 03512 03513 03513 03513 03513 03514 03514 03515 03515 03515 03515 03516

OBDU ZBRO EBS ZBRO EBS ZBRO EBS ZBRO EBS OBDU ZBRO EBS OBDU ZBRO EBS EBS_5 EBS_K1 OBDU ZBRO EBS EBS_5 EBS_K1 ZBRO EBS ZBRO EBS EBS_5 EBS_K1 ZBRO EBS

SD 812a en-online 05.2007

Fault message ESP, no valid error definition ESP, no valid error definition ESP, no CAN communication with ESP CAN databus: Time overrun message RET_CONF_RX_M First faulty EOL LID Brake (ABS/ASR/ EBS) ESP, software incompatible CAN databus: Time overrun message ERC1_RX_M Alternator charge check failure Electrical power supply to trailer ABS ESP, 12/24V incompatible with EBS CAN databus: Time overrun message TANK_INFO Charging voltage too high Brake lamp, tractive unit Brake lamp ESP, no valid error definition CAN databus: Time overrun message ENG_TEMP_M Vehicle system voltage often too low Brake lamp in trailer Brake lamp trailer ESP, ALU test failed CAN databus: Time overrun message ENG_TEMP_M_TIMEOUT_SPN Battery undervoltage after vehicle parked up ESP, output stage defective CAN databus: Time overrun message EFLP_M Charge voltage too low for long period when engine running ESP, intervention not plausible CAN databus: Time overrun message FUEL_ECO_M Vehicle system voltage too low for long period when engine running Battery undervoltage OBD, no valid error definition Starting interlock active OBD, no valid error definition Starting interlock active OBD, no valid error definition Starting interlock request OBD, no valid error definition Retarder actuated ASR button/switch OBD, no valid error definition Engine brake operated ASR button/switch OBD, request, red warning lamp for diagnosis Diagnosis: Request red warning lamp Diagnostic request 'Red warning' Brake pedal pressed ASR control (INA) OBD, request, yellow warning lamp for diagnosis Diagnosis: Request yellow warning lamp Diagnostic request 'Yellow warning' ASR check lamp OBD, no valid error definition ASR control (brake via T-CAN) OBD, brake wear sensor signal Request warning lamp brake pad wear Diagnostic request 'Pad wear warning'; brake pad wear ASR control (engine via T-CAN) OBD, trailer EBS has no errors Page 201 of 276

SPN 03516 03516 03516 03517 03517 03518 03518

Control unit/System EBS_5 EBS_K1 ZBRO EBS ZBRO EBS ZBRO

03519 03519 03519 03520 03520 03520 03521 03521 03521 03522 03522 03522 03522 03522 03523 03523 03523 03524 03524 03524

EBS EBS_K1 ZBRO EBS FFR ZBRO EBS FFR ZBRO EBS EBS_5 EBS_K1 FFR ZBRO EBS FFR ZBRO EBS FFR ZBRO

OBD, wheel speed sensor, error during the last switch-on cycle Engine speed sensor fault during most recent ignition on Brake pressure brake circuit 1 OBD, limit gap speed, warning level, repeated every second Steering column switch timeout (LIN) Brake pressure brake circuit 2 OBD, frequent-stop brake active Multifunctional steering wheel timeout (LIN) Brake pressure rear axle left OBD, chassis dynamometer mode active Diagnosis: Dynamometer test rig mode active Diagnostic mode active Instrumentation timeout (LIN) Brake pressure rear axle right OBD, no valid error definition Multifunctional steering wheel left button side Brake pressure centre axle left OBD, no valid error definition Multifunctional steering wheel right button side Brake pressure centre axle right

03525 03525 03525 03526 03526 03526 03526 03527 03527 03527 03527 03528 03528 03529

EBS FFR ZBRO EBS EBS_5 FFR ZBRO EBS EBS_5 FFR ZBRO EBS ZBRO EBS

03529 03529 03530 03530

EBS_K1 ZBRO EBS_K1 ZBRO

OBD, external wheel alignment (speedo signal/speed sensor) Multifunctional steering wheel left/right button side Brake pressure front axle left OBD, alignment, lateral acceleration sensor not completed Transverse acceleration sensor calibration not completed Steering column stalk Brake pressure front axle right OBD, steering angle sensor, fast alignment not completed Steering angle sensor rapid calibration not completed LIN data bus Brake light OBD, ESP control unit overvoltage or undervoltage Brake lamp centre OBD, ESP is passive Fault in trailer control valve pressure control during most recent ignition on cycle Brake lamp left Fault in pressure control during most recent ignition on cycle Brake lamp right

03531 03531

EBS_K1 ZBRO

03532 03532 03533 03534 03535 03536 03537 03538

EBS_K1 ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO

SD 812a en-online 05.2007

Fault message Request red warning light, ISO 11992 trailer interface Request red warning light, ISO 11992 trailer interface ASR check not connected OBD, voltage too high or too low ASR interface fault OBD, trailer interface in single line mode Brake pad wear indicator

Fault in redundant circuit during most recent ignition on cycle Brake lamp trailer left Incorrect tyre diameter during most recent ignition on cycle, short-term tyre monitoring Brake lamp trailer right Brake pedal position (0...250) EBS brake pad wear indicator EBS brake pad wear indicator EBS check yellow EBS check yellow EBS check yellow not connected Page 202 of 276

SPN 03539 03540 03541 03542 03543 03544 03545 03546 03547 03548 03549 03550 03551 03552 03553 03554 03555 03556 03557 03558 03559 03560 03561 03562 03563 03564 03565 03566 03567 03568 03568 03569 03569 03570 03570 03571 03572 03572 03581 03582 03583 03584 03584 03585 03585 03586 03587 03588 03589 03590 03591 03592 03593 03593 03594 03594 03595 03596 03596 03597

Control unit/System ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO OBDU ZBR2 OBDU ZBR2 OBDU ZBR2 ZBRO OBDU ZBR2 CNG_ME7 CNG_ME7 CNG_ME7 CNG_ME7 TRON CNG_ME7 TRON TRON TRON TRON TRON TRON TRON TRON CNG_ME7 TRON CNG_ME7 TRON CNG_ME7 CNG_ME7 TRON CNG_ME7

SD 812a en-online 05.2007

Fault message EBS air gap too large EBS check red EBS check red not connected EBS malfunction prio. 1 EBS reservoir pressure too low Spring-loaded accumulator reservoir Spring-loaded accumulator reservoir Parking brake 1 5.8 bar (open) Parking brake 2 0.8 bar (close) Bus-stop brake Bus-stop brake Buzzer engage parking brake/door malfunction ABS active (via T-CAN) Malfunction ABS/ASR Check malfunction ABS/ASR EBS/ABS activation (T-CAN) UDS accident data box brake lamp Parking brake fault EBS check yellow (via CAN) EBS check red (via CAN) ABS fully operational Brake pad thickness, 1st axle right Brake pad thickness, 1st axle left Brake pad thickness, 2nd axle right Brake pad thickness, 2nd axle left Brake pad thickness, 3rd axle right Brake pad thickness, 3rd axle left Parking brake 1 forebody Parking brake 1 for FFR Retarder actuated Retarder Engine brake operated Engine brake Brake pedal pressed Service brake Bus stop brake switched off Charge check 2 Bus-stop brake Diagnosis lambda probe before catalytic converter; Heating diagnosis lambda probe before catalytic converter Pressure sensor gas Coding; quality gas Control unit error Temperature gas No ignition – safety time exceeded Flame failure from operation Voltage Flame present during switch-on, cold blowing timeout Flame sensor Actual value temperature control sensor Metering pump Burner motor Solenoid stop valve (gas LD) leaking Glow plug Supply injection valves bank 1 output stage Overheating Supply injection valves bank 2 output stage Stop valve gas 1 output stage (low pressure) Setpoint Stop valve gas 2 output stage (high pressure) Page 203 of 276

SPN 03597 03598 03598 03599 03599 03600

Control unit/System TRON CNG_ME7 TRON CNG_ME7 TRON EBS_K1

03600 03600 03601

TRON ZBR2 CNG_ME7

03601 03601

EBS_K1 OBDU

03601

TRON

03602 03602

EBS_K1 OBDU

03602 03602

TRON ZBR2

03603

EBS_K1

03603 03603

TRON ZBR2

03604 03604 03605 03606 03607 03608 03609

EBS_K1 ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO

03610 03610 03611

EBS_K1 ZBRO ZBRO

03612 03612

EBS_K1 ZBRO

03613 03613 03614 03615 03616 03617 03618 03619

EBS_K1 ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO

03620 03620

EBS_K1 ZBRO

03621 03621 03622

EBS_K1 ZBRO ZBRO

03623 03623

EBS_K1 ZBRO

SD 812a en-online 05.2007

Fault message Overheating sensor Balancing in trailing throttle mode (measuring probe) Warning short-circuit output fresh air signal Balancing in trailing throttle mode (diagnostic probe) Warning short-circuit output theft alarm System bus, general No ignition - Too many unsuccessful start attempts (operation interlock) Fill level, clutch fluid Output stage starter control System bus, monitoring of the axle modulator drive axle messages by central brake unit; CAN brake Front axle above technically permitted axle load Overheating - Hardware threshold exceeded in control unit (operation interlock) System bus, monitoring of the axle modulator additional axle messages by central brake unit; CAN brake Rear axle above technically permitted axle load Overheating - Too many overheatings or hardware threshold exceeded in control unit (operation interlock) Reversing light relay System bus, monitoring of the vehicle dynamics control messages by central brake unit Overheating sensor - Permitted difference from flame sensor exceeded (redundant overheating monitoring) Heating, Kongsberg circuit System bus, monitoring of the steering angle sensor messages by central brake unit Clutch brake shut-off Clutch brake shut-off Clutch brake shut-off Clutch brake shut-off check Clutch brake direct Clutch brake direct stage 1 System bus, monitoring of the central brake unit messages by axle modulator drive axle; CAN brake Clutch brake direct stage 2 Clutch brake direct stage 3 System bus, monitoring of the axle modulator additional axle messages by axle modulator drive axle Gearbox neutral System bus, monitoring of the electronic stability program messages by axle modulator drive axle Current gear (T-CAN) Gear engaged (T-CAN) Selected gear Gear oil too hot Gear oil too hot Reversing light Reverse light left System bus, monitoring of the central brake unit messages by axle modulator additional axle Reverse light right System bus, monitoring of the axle modulator drive axle messages by axle modulator additional axle Gearbox activation (T-CAN) EK shut-off Voith System bus, monitoring of the vehicle dynamics control messages by axle modulator additional axle Neutral at standstill ZF Page 204 of 276

SPN 03624 03625 03626 03627 03628 03629

Control unit/System ZBRO ZBR2 ZBRO ZBRO ZBRO ZBR2

03630

EBS_K1

03631

EBS_K1

03632

EBS_K1

03634 03650 03651 03652 03667 03668 03671 03672 03673 03674 03675 03676 03677 03677 03678 03678 03679 03679 03680 03680 03681 03681 03682 03682 03683 03683 03684 03684 03685 03685 03686 03686 03687 03687 03688 03688 03689 03690 03691 03691 03692 03692 03693 03694 03700 03701 03701

EBS_K1 EBS_K1 EBS_K1 EBS_K1 EDC64 EDC64 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7 EDC7 EDC7 EDC6 EDC7 EDC6 EDC7 EDC7 EDC7 ZBRO EBS_K1 ZBRO

SD 812a en-online 05.2007

Fault message UDS accident data box reversing light Off-road range Reversing light buzzer Gear enable Voith Gearbox oil temperature Transfer case neutral System bus, monitoring of the central brake unit messages by vehicle dynamics control System bus, monitoring of the axle modulator drive axle messages by vehicle dynamics control System bus, monitoring of the axle modulator additional axle messages by vehicle dynamics control System bus, monitoring of the steering angle sensor messages by electronic stability program CAN trailer interface CAN trailer interface, CAN high CAN trailer interface, CAN low Atmospheric pressure pickup Charge pressure pickup Error when reading in EEPROM Error when reading in the fault memory CAN block 2 FFR1: Bank shut-off byte8/bit5-8 Faulty redundant shut-off device afterrun drive Faulty redundant shut-off device afterrun test Charge air low pressure sensor Charge air low pressure sensor Booster voltage bank 1 Booster voltage bank 1 Booster voltage bank 2 Booster voltage bank 2 Current high pressure pump CP3 Current high pressure pump CP3 Starter output stage Starter output stage Averaged control rod position Averaged control rod position Signalling of activation request for output stage Signalling of activation request for output stage Starter output stage monitoring Starter output stage monitoring Activation pulse duty ratio for exhaust gas recirculation valve Activation pulse duty ratio for exhaust gas recirculation valve Activation pulse duty ratio for boost pressure control Activation pulse duty ratio for boost pressure control Pressure relief valve Pressure relief valve does not open Pressure controller variable (pulse duty ratio) Pressure controller variable (pulse duty ratio) Rail pressure control differential Synchronisation state Current equivalent of the pulse duty ratio Current equivalent of the pulse duty ratio Recorded internal temperature EDC Recorded internal temperature EDC Booster voltage Timeout message position 4 Retarder active Vehicle dynamics control module Retarder torque gearbox (T-CAN) Page 205 of 276

SPN 03702 03702 03702 03703 03703 03703 03704

Control unit/System EDC6 EDC7 ZBRO EDC6 EDC7 ZBRO ZBRO

03705 03705

EBS_K1 ZBRO

Vehicle dynamics control system, EEPROM parameter setting Retarder off (button)

03706 03706

EBS_K1 ZBRO

03707 03707 03708 03709 03710 03711 03711 03711 03712 03712 03712 03713 03713 03713 03720 03720 03720 03721 03721 03722 03722 03723 03723 03724 03724 03726 03726 03730 03730 03731 03732 03732 03733 03733 03734 03734 03735 03735 03736 03737

EBS_K1 ZBRO ZBRO ZBRO ZBRO EDC6 EDC7 ZBRO EDC6 EDC7 ZBRO EDC6 EDC7 ZBRO EBS_K1 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7 EBS_K1 EDC7 EBS_K1 EBS_K1 EDC7 EBS_K1 EDC7 EBS_K1 EDC7 EBS_K1 EDC7 EDC7 EDC7

03738

EDC7

Installation, vehicle dynamics control module, vehicle adaptation Retarder off Ensure the ESP components are installed correctly and calibrate the steering angle sensor Retarder off Retarder off check Engine brake off (switch) Engine brake off (button) CAN B block bus off CAN B block bus off Engine brake off CAN B block DPRAM error CAN B block DPRAM error Engine brake off CAN B block error passive CAN B block error passive Engine brake off check Vehicle dynamics control module, electrical power supply Supply to atmospheric pressure sensor Supply to atmospheric pressure sensor Supply to fuel pressure sensor Supply to fuel pressure sensor Supply to charge air low pressure sensor Supply to charge air low pressure sensor Supply to oil pressure sensor Supply to oil pressure sensor Supply to charge air pressure sensor Supply to charge air pressure sensor Supply to fuel low pressure sensor Supply to fuel low pressure sensor Steering angle sensor Defective classification for initialisation (!) Steering angle sensor, voltage transformer signal line Steering angle sensor, calibration Defective classification for initialisation Steering angle sensor, parameter setting High-pressure pump Steering angle sensor, steering ratio Pressure control valve Steering angle sensor signal EDC internal temperature Output stage shut-off by EDC Initialisation in master/slave mode Quantity correction value too great 4-cylinder engine: Cyl. 1; 6cylinder engine: Cyl. 1; 8-cylinder engine: Master cyl. 1, slave cyl. 5; 10-cylinder engine: Master cyl. 1, slave cyl. 6; 12-cylinder engine: Master cyl. 1, slave cyl. 12

SD 812a en-online 05.2007

Fault message CAN A block DPRAM error CAN A block DPRAM error Retarder torque engine control (T-CAN) CAN A block error passive CAN A block error passive Retarder activation (T-CAN) Retarder off (switch)

Page 206 of 276

SPN

Control unit/System

03739

EDC7

03740

EDC7

03741

EDC7

03742

EDC7

03743 03744

EDC7 EDC6

03744 03745 03746 03747

EDC7 EDC7 EDC7 EDC7

03748 03749 03750 03750 03751 03752

EDC7 EDC7 EBS_5 EDC7 EDC7 EDC7

03753 03753

EBS_5 EDC7

03754 03754 03755 03756

EBS_5 EDC7 EDC7 EBS_5

03756 03757

EDC7 EBS_5

Highside output stage metering unit high-pressure pump CP3 Highside output stage engine air flow sensor flap ESP sensor gateway, ESP sensor voltage supply fault Highside output stage RH 07 Highside output stage starter relay Segment encoder (camshaft) ESP sensor gateway, time overrun in communication with steering angle sensor Incremental encoder (crankshaft) ESP sensor gateway, time overrun in communication with yaw rate sensor Monitoring error when system starts Plausibility fuel supply pressure ESP sensor gateway, faulty steering angle sensor signal Supply voltage exhaust gas recirculation system checkback, exhaust differential pressure ESP sensor gateway, faulty yaw rate sensor signal

03758 03758 03759 03759 03760 03761 03762 03763 03764 03765 03766 03767 03768 03769 03771 03772 03773 03774

EBS_5 EDC7 EBS_5 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7

ESP sensor gateway, faulty lateral acceleration sensor signal Send error message slot 2 to partner EDC ESP sensor gateway, steering angle sensor not calibrated Send error message slot 3 to partner EDC Send error message slot 4 to partner EDC Send error message slot 5 to partner EDC Timeout of the CAMD_ANA message Timeout of the CAMD_CMOL message Timeout of the CAMD_CONTROL message Timeout of the CAMD_FFR1 message Timeout of the CAMD_FFR2 message Timeout of the CAMD_FFR3 message Fault status of the CAMD_INIT message Timeout of the CAMD_Limit message Master/slave CAN fault in partner control unit Monitoring terminal 15 master/slave Operating mode change error master/slave Temporary CMOL mode of the partner EDC

SD 812a en-online 05.2007

Fault message Quantity correction value too great 4-cylinder engine: Cyl. 3; 6cylinder engine: Cyl. 5; 8-cylinder engine: Master cyl. 2, slave cyl. 7; 10-cylinder engine: Master cyl. 5, slave cyl. 10; 12-cylinder engine: Master cyl. 5, slave cyl. 8 Quantity correction value too great 4-cylinder engine: Cyl. 4; 6cylinder engine: Cyl. 3; 8-cylinder engine: Master cyl. 3, slave cyl. 6; 10-cylinder engine: Master cyl. 2, slave cyl. 7; 12-cylinder engine: Master cyl. 3, slave cyl. 10 Quantity correction value too great 4-cylinder engine: Cyl. 2; 6cylinder engine: Cyl. 6; 8-cylinder engine: Master cyl. 4, slave cyl. 8; 10-cylinder engine: Master cyl. 3, slave cyl. 8; 12-cylinder engine: Master cyl. 6, slave cyl. 7 Quantity correction value too great 6-cylinder engine: Cyl. 2; 10cylinder engine: Master cyl. 4, slave cyl. 9; 12-cylinder engine: Master cyl. 2, slave cyl. 11 Quantity correction value too great 6-cylinder engine: Cyl. 4; 12cylinder engine: Master cyl. 4, slave cyl. 9 Highside output stage electrical charger Highside output stage exhaust gas recirculation system throttle butterfly Highside output stage charge air pressure governing system Highside output stage exhaust gas recirculation system Highside output stage pressure governing valve

Page 207 of 276

SPN 03775 03775

Control unit/System EDC6 EDC7

03776

EDC6

03776

EDC7

03777

EDC6

03777 03778 03778 03779 03779 03780 03780 03781 03781 03782 03782

EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7

03783

EDC6

03783 03784 03784

EDC7 EDC6 EDC7

03785

EDC6

03785 03786 03786 03787 03787 03788 03788

EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7

Fault message Rail pressure monitoring Rail pressure monitoring Excessive positive control differential (control system cannot compensate for too low rail pressure) Excessive positive control differential (control system cannot compensate for too low rail pressure) Excessive negative control differential (control system cannot compensate for too high rail pressure) Excessive negative control differential (control system cannot compensate for too high rail pressure) Rail pressure: Leakage in overrun conditions Rail pressure: Leakage in overrun conditions Rail pressure: Leakage due to quantity compensation Rail pressure: Leakage due to quantity compensation Rail pressure: High controller output when idling Rail pressure: High controller output when idling Pressure relief valve open (pressure too high) Pressure relief valve open (pressure too high) Fuel supply pressure dynamic Fuel supply pressure dynamic FFR (vehicle management computer) 2: Bit error max. permitted engine acceleration FFR (vehicle management computer) 2: Bit error max. permitted engine acceleration Bit error smoke ID Bit error smoke ID Monitoring particle filter/PM catalytic converter, differential exhaust pressure too high or too low Monitoring particle filter/PM catalytic converter, differential exhaust pressure too high or too low Particulate filter temperature limits Particulate filter temperature limits No particulate filter regeneration No particulate filter regeneration Exhaust gas differential or exhaust gas relative pressure Exhaust gas differential or exhaust gas relative pressure

03789

EDC6

Exhaust gas differential or exhaust gas relative pressure sensor

03789

EDC7

03790

EDC6

03790 03791 03791 03792 03792 03793 03793 03794 03794 03795 03795 03796 03796 03797 03797 03798 03798

EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7 EDC6 EDC7

Exhaust gas differential or exhaust gas relative pressure sensor Exhaust gas differential or exhaust gas relative pressure plausibility Exhaust gas differential or exhaust gas relative pressure plausibility Exhaust temperature before exhaust post-treatment Exhaust temperature before exhaust post-treatment Exhaust temperature sensor before exhaust post-treatment Exhaust temperature sensor before exhaust post-treatment Exhaust temperature after exhaust post-treatment Exhaust temperature after exhaust post-treatment Exhaust temperature sensor after exhaust post-treatment Exhaust temperature sensor after exhaust post-treatment Exhaust gas recirculation throttle butterfly Exhaust gas recirculation throttle butterfly Highside output stage exhaust gas recirculation system 2 Highside output stage exhaust gas recirculation system 3 Highside output stage lambda probe Highside output stage lambda probe Output stage OBD lamp (MIL) Output stage OBD lamp (MIL)

SD 812a en-online 05.2007

Page 208 of 276

SPN 03799 03799 03800 03800 03800 03801 03801 03801 03802 03802 03802

Control unit/System EDC6 EDC7 EDC6 EDC7 ZBR2 EDC6 EDC7 OBDU EDC6 EDC7 OBDU

03803

EDC6

03803

EDC7

03804

EDC6

03804

EDC7

Fault message Highside output stage reserve 01 Highside output stage reserve 01 Highside output stage reserve 02 Highside output stage reserve 02 Air suspension/ECAS Highside output stage reserve 03 Highside output stage reserve 03 No engine start for at least 3 weeks Highside output stage stop valve compressed air Highside output stage stop valve compressed air No engine start for at least 10 weeks Engine CAN transmit error, no message available in vehicle management computer Engine CAN transmit error, no message available in vehicle management computer Engine CAN receive error, not possible to receive a message from vehicle management computer Engine CAN receive error, not possible to receive a message from vehicle management computer

03805

EDC6

Master/slave CAN communication disrupted, bus load too high

03805 03806 03806 03806

EDC7 EDC6 EDC7 ZBRO

03807

EDC6

03807 03807

EDC7 ZBRO

03808

EDC6

03808

EDC7

03809

EDC6

03809 03809

EDC7 ZBRO

03810

EDC6

03810 03810

EDC7 ZBRO

Master/slave CAN communication disrupted, bus load too high Master/slave CAN communication disrupted, receive error Master/slave CAN communication disrupted, receive error Raise bus again Vehicle management computer sends invalid value in FFR1 message Vehicle management computer sends invalid value in FFR1 message Raise bus again Vehicle management computer sends invalid value in FFR2 message Vehicle management computer sends invalid value in FFR2 message Vehicle management computer sends invalid value in FFR3 message Vehicle management computer sends invalid value in FFR3 message ECAS malfunction Vehicle management computer sends invalid numerical value, date/time error Vehicle management computer sends invalid numerical value, date/time error ECAS warning

03811 03811

EDC7 ZBRO

Exhaust temperature plausibility before exhaust post-treatment ECAS governing suppression brake

03812 03812 03813 03813 03814 03814 03815 03815 03816 03816 03817

EDC7 ZBRO EDC7 ZBRO EDC7 ZBRO EDC7 ZBRO EDC7 ZBRO EDC7

Exhaust temperature plausibility after exhaust post-treatment Kneeling lowering Starter monitoring Kneeling lowering Recording of control unit switch-off duration Kneeling fully lowered Exhaust backpressure Kneeling fully lowered Exhaust backpressure sensor Kneeling raise Permanent system deviation exhaust backpressure

SD 812a en-online 05.2007

Page 209 of 276

SPN 03817 03818 03818 03819 03819 03820 03820

Control unit/System ZBRO EDC7 ZBRO EDC7 ZBRO EDC7 ZBRO

03821 03821 03822 03822 03823 03823

EDC7 ZBRO EDC7 ZBRO EDC7 ZBRO

03824 03824

EDC7 ZBRO

03825 03825

EDC7 ZBRO

03826 03826

EDC7 ZBRO

03827 03827

EDC7 ZBRO

03828 03828 03829 03829

EDC7 ZBRO EDC7 ZBRO

03830 03830

EDC7 ZBRO

03831 03831

EDC7 ZBRO

03832 03832

EDC7 ZBRO

03833 03833

EDC7 ZBRO

03834 03834

EDC7 ZBRO

03835 03835 03836 03836 03837 03837 03838 03838 03839

EDC7 ZBRO EDC7 ZBRO EDC7 ZBRO EDC7 ZBRO EDC7

SD 812a en-online 05.2007

Fault message Kneeling raise Exhaust backpressure plausibility Kneeling, manual/automatic CAN block 3 Kneeling automatic Byte monitoring CAN 1 (oil, ambient and air temperature) Kneeling automatic check Byte monitoring CAN 3 (exhaust temperature, AdBlue fill level, AdBlue temperature) Kneeling raise control unit (16) Time overrun CAN 3, exhaust CAN Kneeling emergency raise Misfiring on several cylinders Kneeling emergency raise Misfiring status master 8-cylinder engine: Cylinder 1; 10-cylinder engine: Cylinder 1; 12-cylinder engine: Cylinder 1 Kneeling emergency raise prio. 1 Misfiring status master 8-cylinder engine: Cylinder 2; 10-cylinder engine: Cylinder 5; 12-cylinder engine: Cylinder 5 Kneeling key-operated switch Misfiring status master 8-cylinder engine: Cylinder 3; 10-cylinder engine: Cylinder 2; 12-cylinder engine: Cylinder 3 Kneeling lower control unit (19) Misfiring status master 8-cylinder engine: Cylinder 4; 10-cylinder engine: Cylinder 3; 12-cylinder engine: Cylinder 6 Kneeling door open Misfiring status master 10-cylinder engine: Cylinder 4; 12cylinder engine: Cylinder 2 Air suspension reservoir too low Misfiring status master 12-cylinder engine: Cylinder 4 Air suspension reservoir too low Misfiring status 4-cylinder engine: Cylinder 1; 6-cylinder engine: Cylinder 1; slave 8-cylinder engine: Cylinder 5; 10-cylinder engine: Cylinder 6; 12-cylinder engine: Cylinder 12 v 3 km/h or door interlock Misfiring status 4-cylinder engine: Cylinder 4; 6-cylinder engine: Cylinder 3; slave 8-cylinder engine: Cylinder 6; 10-cylinder engine: Cylinder 7; 12-cylinder engine: Cylinder 10 Moving-off aid Misfiring status 4-cylinder engine: Cylinder 2; 6-cylinder engine: Cylinder 6; slave 8-cylinder engine: Cylinder 8; 10-cylinder engine: Cylinder 8; 12-cylinder engine: Cylinder 7 Moving-off aid Misfiring status 6-cylinder engine: Cylinder 2; slave 10-cylinder engine: Cylinder 9; 12-cylinder engine: Cylinder 11 Moving-off aid check Misfiring status 6-cylinder engine: Cylinder 4; slave 12-cylinder engine: Cylinder 9 Moving-off aid switch-off Lambda probe sensor acquisition Lifting bus above normal level Lambda probe acquisition Lifting bus above normal level Lambda probe internal resistance, physical Lowering bus again Lambda probe internal resistance Page 210 of 276

SPN 03839 03840 03840 03841 03841 03842 03842 03843 03843 03844 03844 03845 03845 03846 03846

Control unit/System ZBRO EDC7 ZBRO EDC7 ZBRO EDC7 ZBRO EDC7 ZBRO EDC7 ZBRO EDC7 ZBRO EDC7 ZBRO

03847 03847 03848 03848 03849 03849 03850 03850 03851 03852

EDC7 ZBRO EDC7 ZBRO EDC7 ZBRO EDC7 ZBRO EDC7 EDC7

03853 03854 03855 03856 03857 03858 03859 03860 03861

EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7

03862

EDC6

03862 03863

EDC7 EDC7

03864

EDC7

03865

EDC7

03866

EDC7

03867 03868 03869 03870 03871 03872 03873

EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7

03874

EDC7

03875

EDC7

SD 812a en-online 05.2007

Fault message Lowering bus below ride height Oil temperature sensor Lowering bus below ride height Coolant pressure sensor Bus normal level Coolant pressure plausibility ECAS activation (T-CAN) Coolant temperature plausibility Kneeling start interlock Plausibility, temperature ahead of cylinder inlet NLA bellows is depressurised (p < 0.3 bar) Ambient air temperature plausibility Switch off NLA bellows depressurisation Control unit configuration Driven axle pressurised (p > 8.4 bar) Boost air temperature sensor after cooler (before exhaust gas recirculation) ECAS malfunction flashing at 1 Hz Ambient air temperature sensor ECAS malfunction continuous light Catalyser not installed ECAS warning or malfunction 2 Hz Position deviation enclosed exhaust gas recirculation ECAS warning flashing at 1 Hz Exhaust gas recirculation flap position sensor Exhaust gas recirculation temperature plausibility Permanent system deviation position-controlled exhaust gas recirculation EDC internal temperature sensor 2 Lambda probe system Lambda probe calibration Lambda probe communication Lambda probe temperature Lambda probe temperature calibration Turbine wheel speed Turbine wheel speed sensor NBF pulses without quantity requests (redundant control travel monitoring) NBF pulses without quantity requests (redundant control travel monitoring) Trailing throttle monitoring Injection monitoring; battery voltage too low for advanced injection Injection monitoring; battery voltage too low for second advanced injection Injection monitoring; battery voltage too low for second main injection Injection monitoring; battery voltage too low for second postinjection Charge air temperature after intercooler plausibility Oil temperature plausibility Fuel temperature plausibility EDC internal temperature plausibility EDC internal cooling bracket temperature plausibility EDC was in an undefined condition. A reset was performed. Quantity correction value too large: Segment 0. Injector is contaminated or leaking. Quantity correction value too large: Segment 1. Injector is contaminated or leaking. Page 211 of 276

SPN

Control unit/System

03876

EDC7

03877

EDC7

03878

EDC7

03879 03880 03881 03882 03883 03884 03885 03886 03887 03888 03889 03890 03891 03892 03893 03894 03895 03896 03897 03898

EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7

03899

EDC7

03900

EDC7

03901

EDC7

03902

EDC7

03903 03903 03904 03905 03905 03906 03906 03907 03907 03908

EDC7 ZBR2 OBDU EDC7 OBDU EDC7 OBDU EDC7 OBDU EDC7

03909 03909 03910 03911

EDC7 OBDU EDC7 EDC7

Unfiltered exhaust gas temperature after exhaust post-treatment Measured voltage of the exhaust gas temperature sensor after exhaust post-treatment Tank/ fuel level Reservoir pressure circuit 1 (too low) Exhaust post-treatment temperature difference Reservoir pressure circuit 2 (too low) A start request has been received and no fault has occurred. Reservoir pressure circuit 3 (too low) Measuring timer for cooling time Reservoir pressure circuit 4 (too low) Charge air temperature ahead of cylinder intake Measured voltage of the charge air temperature sensor ahead of engine Previous circuit defective Nominal exhaust gas recirculation value Adapted valve position as ratio value

03912

EDC7

Measured voltage of the exhaust gas recirculation flap position

03913 03913 03914 03915 03915

EDC7 OBDU EDC7 EDC7 OBDU

Zero point voltage of the exhaust gas recirculation valve position ECAM in pneumatic backup, CAN OK Unfiltered charge air temperature at cylinder inlet Measured voltage of internal EDC temperature ASR engine governor failure

SD 812a en-online 05.2007

Fault message Quantity correction value too large: Segment 2. Injector is contaminated or leaking. Quantity correction value too large: Segment 3. Injector is contaminated or leaking. Quantity correction value too large: Segment 4. Injector is contaminated or leaking. Quantity correction value too large: Segment 5. Injector is contaminated or leaking. Output stage 12V for LIN bus Switch-off duration of EDC in minutes Maximum value of rail pressure voltage Unfiltered exhaust gas differential pressure Unfiltered oil pressure Unfiltered boost pressure Unfiltered charge air temperature ahead of cylinder insert Unfiltered atmospheric pressure Unfiltered coolant temperature External ambient air temperature Unfiltered exhaust temperature Unfiltered charge air temperature ahead of engine Minimum value for rail pressure sensor voltage Measured voltage of boost pressure sensor Measured voltage of coolant temperature sensor Measured voltage of fuel pressure sensor Measured voltage of fuel supply pressure sensor Kickoff Measured voltage of internal EDC temperature 2 Measured voltage of exhaust gas differential pressure or exhaust gas relative pressure sensor Difference between pressure values at maximum and minimum boost pressure Measured voltage of the exhaust gas temperature sensor before exhaust post-treatment

Page 212 of 276

SPN

Control unit/System

03916

EDC7

03918 03918 03919 03919 03920 03920 03921 03923 03924 03925 03926 03927

EDC7 ZBRO EDC7 ZBR2 EDC7 ZBR2 EDC7 EDC7 EDC7 EDC7 EDC7 EDC7

Fault message Difference in temperature values with two different boost pressure values Measured voltage of the charge air temperature sensor at cylinder inlet Fuel tank almost empty Fault status nitrogen oxide (NOx) sensor heating Fill level Gas2 Fault status nitrogen oxide (NOx) concentration Fill level Gas3 Fault status oxygen (O2) concentration Coolant temperature 2 Unfiltered coolant temperature 2 Coolant temperature sensor 2 Gradient monitoring RDS Detection of non-fitted lambda probe

03929

EDC7

Monitoring of exhaust gas recirculation with lambda (MIL error)

03930 03931 03932 03940 03941 04000 04000 04000 04000 04000 04000 04000 04001

EDC7 EDC7 EDC7 EDC7 EDC7 AST EBS_5 EDC6 EDC7 TBM ZBR2 ZBRO AST

04001

EBS_5

04001

EDC6

04001 04001 04001 04001 04001 04001 04001 04002 04002 04002 04002 04002 04002 04002 04002 04003

EDC7 EMOS INT SFFR TBM ZBR2 ZBRO AST EBS_5 EMOS INT SFFR TBM ZBR2 ZBRO AST

04003 04003 04003 04003 04003 04004 04004

EBS_5 INT SFFR TBM ZBR2 AST EBS_5

Monitoring of exhaust gas recirculation with lambda (PR error) Output stage PWM19 Output stage PWM30 Recovery type of the most recently saved recoveries Recovery type of the most recently saved recoveries Foot off accelerator pedal (!) Central control unit - B-controller: Brake performance test Communication fault to CRT control unit Communication fault to CRT control unit No response to DM4 request to control unit 0 External lighting Headlight low beam Low air pressure Central control unit - A-controller: Checksum error in configuration RAM Exhaust temperature too high or communication fault to CRT control unit Exhaust temperature too high or communication fault to CRT control unit System pressure or switch-on duration of actuators Accumulator charge valve Selector lever position No response to DM4 request to control unit 1 Headlight low beam, left Low beam left Clutch overload Central control unit - A-controller: Internal data memory Clutch overload Engine brake request Speed request ship vehicle management computer No response to DM4 request to control unit 2 Headlight low beam, right Low beam right Clutch word (!) Central control unit - B-controller: ESP intervention implausible Intarder check lamp Terminal 15 No response to DM4 request to control unit 3 Right headlight adjustment Clutch wear ESP logic, incorrect configuration

SD 812a en-online 05.2007

Page 213 of 276

SPN 04004 04004 04004 04004 04004

Control unit/System HVA INT SFFR TBM ZBR2

04005 04005 04005 04005 04005 04005

EBS_5 INT SFFR TBM ZBR2 ZBRO

04006 04006 04006 04006 04006

EBS_5 INT TBM ZBR2 ZBRO

04007 04007 04007 04007 04007 04007

EBS_5 HVA INT TBM ZBR2 ZBRO

04008 04008 04008 04008 04008 04008 04009 04009 04009 04009 04009

EBS_5 HVA INT TBM ZBR2 ZBRO EBS_5 HVA INT TBM ZBR2

04010 04010 04010 04010 04010

EBS_5 HVA INT TBM ZBR2

04011 04011 04011 04011 04011 04011

EBS_5 HVA INT TBM ZBR2 ZBRO

04012 04012 04012 04012 04012 04012 04013

EBS_5 HVA INT TBM ZBR2 ZBRO EBS_5

04013

HVA

SD 812a en-online 05.2007

Fault message EEPROM error Display, temperature reduction Voltage selector lever No response to DM4 request to control unit 4 Left headlight adjustment Central control unit - B-controller: Pressure regulating valves (ABS) are in an undefined status Brake lamp output Voltage pedal value sensor No response to DM4 request to control unit 5 Turn indicators, tractive unit, rear left Turn indicator rear left bottom (!) Central control unit - B-controller: Calculated ISC pressures in A and B-controller do not match Fault lamp output No response to DM4 request to control unit 6 Turn indicators, tractive unit, rear right Turn indicator rear right bottom (!) ABS logic, FMI 3 = Pressure plausibility / FMI 8 = Data record plausibility Failure of CAN message CCVeh_Speed Cruise control shut-off No response to DM4 request to control unit 7 Turn indicator, tractive unit s/f, left Turn indicator front left side ABS (pressure control valve): Installed but no components configured Failure of CAN message EBC2 Braking level selector supply No response to DM4 request to control unit 8 Turn indicator, tractive unit s/f, right Turn indicator front right side Central control unit Failure of CAN message EEC1 Proportional valve No response to DM4 request to control unit 9 Hall sensor, indicator stalk switch RL Central control unit - Internal controller communication of the Acontroller, checksum error Failure of CAN message EBC1 Earth return, proportional valve No response to DM4 request to control unit 10 Hall sensor, indicator stalk switch RR Central control unit - Internal controller communication of the Acontroller, interruption in communication ABS signals 'Not fully operational' Output ADM2 No response to DM4 request to control unit 11 Switch, indicators, left (button) Turn indicator, left Central control unit - Internal controller communication of the Acontroller, format error Cable fault oil temperature sensor (pin III/3 or IV/18) Speed sensor, gearbox output No response to DM4 request to control unit 12 Switch, indicators, right (button) Turn indicator, right Central control unit - A-controller, format error Oil pressure sensor signals 'No oil pressure' or engine stalled Page 214 of 276

SPN 04013 04013 04013 04013

Control unit/System INT TBM ZBR2 ZBRO

04014 04014 04014 04014 04014 04014

EBS_5 HVA INT TBM ZBR2 ZBRO

04015 04015 04015 04015 04015 04015

EBS_5 HVA INT TBM ZBR2 ZBRO

04016 04016 04016 04016 04016 04016

EBS_5 HVA INT TBM ZBR2 ZBRO

04017 04017 04017 04017 04017 04017

EBS_5 HVA INT TBM ZBR2 ZBRO

04018 04018 04018 04018 04018

EBS_5 INT TBM ZBR2 ZBRO

04019 04019 04019 04019 04019 04019

EBS_5 HVA INT TBM ZBR2 ZBRO

04020 04020 04020 04020 04020 04020

EBS_5 HVA INT SFFR TBM ZBR2

04021 04021 04021 04021 04021 04021

EBS_5 INT SFFR TBM ZBR2 ZBRO

SD 812a en-online 05.2007

Fault message Temperature detection, system error No response to DM4 request to control unit 13 Check lamp, hazard warning lights Hazard warning lights check Central control unit - Internal controller communication of the Bcontroller, checksum error Oil pressure sensor signals 'Continuous oil pressure' Readback current, proportional valve No response to DM4 request to control unit 14 Hazard warning light switch Hazard warning light switch Central control unit - Internal controller communication of the Bcontroller interruption in communication Cable fault oil pressure sensor (pin III/4, II/5 or I/5) Power supply No response to DM4 request to control unit 15 Turn indicators in trailer, left Turn indicator left trailer Central control unit - Internal controller communication of the Bcontroller, format error Fault at output ZP1 (pin IV/11) Braking level selector No response to DM4 request to control unit 16 Turn indicators in trailer, right Turn indicator right trailer Central control unit EEPROM: Implausible values in 'General vehicle configuration' block Fault at output ZP2 (pin IV/2 or IV/6) Operating hours counter, system error No response to DM4 request to control unit 17 Headlight high beam, left High beam 1 left Central control unit EEPROM: Checksum error in 'General vehicle configuration' block Faul memory, system error No response to DM4 request to control unit 18 Headlight high beam, right High beam 1 right Central control unit EEPROM: Implausible values in 'Own vehicle configuration' block Fault at output ZP3 (pin III/13) CAN data bus No response to DM4 request to control unit 19 Switch, headlight high beam (button) High beam switch Central control unit EEPROM: Checksum error in 'Own vehicle configuration' block Fault at output clutch main pump (pin IV/7 and III/5) Data bus, message EEC2 from EDC Supply voltage No response to DM4 request to control unit 20 Headlight flash button Central control unit EEPROM: Implausible values in 'General wheel configuration' block Engine speed sensor Pedal value sensor No response to DM4 request to control unit 21 Auxiliary high beam, left High beam 2 left Page 215 of 276

SPN

Control unit/System

04022 04022 04022 04022 04022 04022 04022

EBS_5 HVA INT SFFR TBM ZBR2 ZBRO

04023 04023 04023 04023 04023 04023

EBS_5 HVA INT SFFR TBM ZBR2

04024 04024 04024 04024 04024 04024 04024

EBS_5 HVA INT SFFR TBM ZBR2 ZBRO

04025 04025 04025 04025 04025 04025 04025

EBS_5 HVA INT SFFR TBM ZBR2 ZBRO

04026 04026 04026 04026 04026 04026 04026

EBS_5 HVA INT SFFR TBM ZBR2 ZBRO

04027 04027 04027

EBS_5 HVA INT

04027 04027 04027 04027

SFFR TBM ZBR2 ZBRO

04028 04028

EBS_5 INT

04028 04028 04028

SFFR TBM ZBR2

04029 04029

EBS_5 INT

Engine CAN: Time overrun when receiving EDC message EDC2 No response to DM4 request to control unit 28 Switch-on enable check lamp, fog lamps Central control unit EEPROM: Implausible values in 'General function configuration' block CAN data bus, message TCO1 from tachograph

04029

SFFR

Engine CAN: Time overrun when receiving EDC message EDC3

SD 812a en-online 05.2007

Fault message Central control unit EEPROM: Checksum error in 'General wheel configuration' block Fault at output fan relay (pin III/10) System fault Selector lever No response to DM4 request to control unit 22 Auxiliary high beam, right High beam 2 right Central control unit EEPROM: Implausible values in 'General axle configuration' block Speed signals implausible CAN data bus, message TSC1 from FFR Idling speed harmonisation No response to DM4 request to control unit 23 Relay, additional headlight in roof Central control unit EEPROM: Checksum error in 'General axle configuration' block Operating voltage too low CAN data bus, send system error Default driving unit No response to DM4 request to control unit 24 Rear fog lamp, tractive unit Rear fog lamp Central control unit EEPROM: Implausible values in 'Own axle configuration' block Warning note: Oil temperature too high CAN data bus, BusOff Engine CAN No response to DM4 request to control unit 25 Rear fog lamp, trailer Rear fog lamp trailer Central control unit EEPROM: Checksum error in 'Own axle configuration' block Failure of CAN message Ambient Condition CAN data bus, message EBC1 from EBS/ABS MMDS CAN No response to DM4 request to control unit 26 Fog lamp, right Fog lamp right Central control unit EEPROM: Implausible values in 'General CAN configuration' block Failure of CAN message ERC1_RMC CAN data bus, acknowledge system error Engine CAN: Time overrun when receiving EDC message EDC1 No response to DM4 request to control unit 27 Fog lamp, left Fog lamp left Central control unit EEPROM: Checksum error in 'General CAN configuration' block CAN data bus, message EEC1 from EDC

Page 216 of 276

SPN 04029 04029

Control unit/System TBM ZBR2

04030 04030

EBS_5 INT

04030 04030 04030

SFFR TBM ZBR2

04031 04031

EBS_5 INT

04031 04031 04031

SFFR TBM ZBR2

04032 04032

EBS_5 INT

04032 04032 04032

SFFR TBM ZBR2

04033 04033

EBS_5 INT

04033 04033 04033

SFFR TBM ZBR2

04034 04034

EBS_5 INT

04034 04034 04034

SFFR TBM ZBR2

04035 04035

EBS_5 INT

04035 04035 04035

SFFR TBM ZBR2

04036 04036 04036 04036 04036

EBS_5 INT TBM ZBR2 ZBRO

04037 04037 04037 04037 04037

EBS_5 INT TBM ZBR2 ZBRO

04038 04038 04038

EBS_5 INT TBM

SD 812a en-online 05.2007

Fault message No response to DM4 request to control unit 29 Relay, additional fog lamps Central control unit EEPROM: Checksum error in 'General function configuration' block LED Engine CAN: Time overrun when receiving EDC message EDC4 No response to DM4 request to control unit 30 Current, parking light, tractive unit, right Central control unit EEPROM: Implausible values in 'General ISR configuration' block CAN data bus, message CCVS from FFR Engine CAN: Time overrun when receiving EDC message EDC5 No response to DM4 request to control unit 31 Current, parking light, tractive unit, left Central control unit EEPROM: Checksum error in 'General ISR configuration' block CAN data bus, message ERC1_ER from EDC Engine CAN: Time overrun when receiving EDC message EngineConfig No response to DM4 request to control unit 32 Current, parking light, right Central control unit EEPROM: Implausible values in 'Own ISR configuration' block CAN data bus, message ETC1 from gearbox MMDS CAN: Time overrun when receiving MMDS message TSC1-FME. No response to DM4 request to control unit 33 Current, parking light, left Central control unit EEPROM: Checksum error in 'Own ISR configuration' block CAN data bus, message ETC1 from FFR MMDS CAN: Time overrun when receiving MMDS message Time/Date No response to DM4 request to control unit 34 Side marker light, right Central control unit EEPROM: Implausible values in 'Own ABS configuration' block CAN data bus, message ETP from EDC MMDS CAN: Time overrun when receiving MMDS message VehDistance No response to DM4 request to control unit 35 Side marker light, left Central control unit EEPROM: Checksum error in 'Own ABS configuration' block CAN data bus, message ERC1 from FFR No response to DM4 request to control unit 36 Current, parking light, trailer, right Tail light right trailer Central control unit EEPROM: Implausible values in 'Own ASR configuration' block CAN data bus, message TSC1 from FFR No response to DM4 request to control unit 37 Current, parking light, trailer, left Tail light left trailer Central control unit EEPROM: Checksum error in 'Own ASR configuration' block CAN data bus, time/date message from tachograph No response to DM4 request to control unit 38 Page 217 of 276

SPN 04038

Control unit/System ZBR2

04039 04039 04039 04039 04039

EBS_5 INT TBM ZBR2 ZBRO

04040 04040 04040 04040

EBS_5 INT TBM ZBR2

04041 04041 04041 04041

EBS_5 INT TBM ZBR2

04042 04042 04042 04042

EBS_5 INT TBM ZBR2

04043 04043 04043 04043

EBS_5 INT TBM ZBR2

04044 04044 04044 04044

EBS_5 INT TBM ZBR2

04045 04045 04045 04045

EBS_5 INT TBM ZBR2

04046 04046 04046

EBS_5 TBM ZBR2

04047 04047 04047 04047

EBS_5 INT TBM ZBRO

04048 04048 04048

EBS_5 TBM ZBRO

04049 04049 04049 04050 04050 04050 04051 04051 04051

EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO

SD 812a en-online 05.2007

Fault message Relay, parking lights left Central control unit EEPROM: Implausible values in 'General ESP configuration' block CAN data bus, mileage message (HRVD) from tachograph No response to DM4 request to control unit 39 Parking light switch Parking light switch Central control unit EEPROM: Checksum error in 'General ESP configuration' block Lamp, Bremsomat/braking control active No response to DM4 request to control unit 40 Winter service relay Central control unit EEPROM: Implausible values in 'Own ESP configuration' block CAN data bus, ABS message from EBS/ABS No response to DM4 request to control unit 41 Relay, blackout light Central control unit EEPROM: Checksum error in 'Own ESP configuration' block CAN data bus, FMR1 message from FFR No response to DM4 request to control unit 42 Perform lighting training again Central control unit EEPROM: Implausible values in 'Own plausibility configuration' block Flashing code lamp No response to DM4 request to control unit 43 Interlock function, light test Central control unit EEPROM: Checksum error in 'Own plausibility configuration' block CAN data bus, message FMR2 No response to DM4 request to control unit 44 Release function, light test Central control unit EEPROM: Implausible values from 'Error memory' CAN data bus, message EPS No response to DM4 request to control unit 45 Turn indicators operated for both directions Central control unit EEPROM: Checksum error for 'Error memory' No response to DM4 request to control unit 46 ALW not calibrated Central control unit EEPROM: Implausible values in 'Axle configuration' block Vehicle electrical system terminal 30 No response to DM4 request to control unit 47 Turn indicator rear left top Central control unit EEPROM: Checksum error in 'Self-taught EBS data' block No response to DM4 request to control unit 48 Turn indicator rear right top Central control unit EEPROM: Checksum error in 'Own test' block No response to DM4 request to control unit 49 Turn indicator rear left side Brakes CAN No response to DM4 request to control unit 50 Turn indicator rear right side ESP sensor CAN: System bus off No response to DM4 request to control unit 51 Turn indicator front left Page 218 of 276

SPN

Control unit/System

04052 04052 04052 04053 04053 04053 04054 04054 04054 04055 04055 04055

EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO

04056 04056 04056 04057 04057 04057 04058 04058 04058 04059 04059 04059 04060 04060 04060 04061 04061 04061 04062 04062 04062 04063 04063 04063 04064 04064 04064 04065 04065 04065 04066 04066 04066 04067 04067 04067 04068 04068 04068

EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO

04069 04069 04069 04070 04070 04070

EBS_5 TBM ZBRO EBS_5 TBM ZBRO

SD 812a en-online 05.2007

Fault message Electrical power supply, comparison between terminal 15 and terminal 30 No response to DM4 request to control unit 52 Turn indicator front right Earth 2 No response to DM4 request to control unit 53 School bus button Control unit switch-off delay: Fault in electronic circuit No response to DM4 request to control unit 54 School bus button ASR: Invalid configuration No response to DM4 request to control unit 55 School bus button check Central control unit - B-controller: Checksum error in boot software No response to DM4 request to control unit 56 Additional turn indicator behind bumper Pressure control valve No response to DM4 request to control unit 57 Clicker relay (!) Steering angle sensor, CAN communication No response to DM4 request to control unit 58 Hazard warning light switch CAN (!) Steering angle sensor signal No response to DM4 request to control unit 59 Hazard warning light switch external Steering angle sensor, installed but not configured No response to DM4 request to control unit 60 Headlight high beam (!) Yaw rate sensor, quick calibration faulty No response to DM4 request to control unit 61 High-beam headlight check (!) Yaw rate sensor signal No response to DM4 request to control unit 62 Licence plate light(s) (!) Yaw rate sensor, CAN communication No response to DM4 request to control unit 63 Rear fog lamp (!) Yaw rate sensor, sensor installed incorrectly No response to DM4 request to control unit 64 Rear fog lamp right Yaw rate sensor, installed but not configured No response to DM4 request to control unit 65 Rear fog lamp left (!) Lateral acceleration sensor, long-time calibration incorrect No response to DM4 request to control unit 66 Rear fog lamp trailer right (!) Transverse acceleration sensor signal No response to DM4 request to control unit 67 Rear fog lamp trailer left (!) Steering angle sensor, long-time calibration incorrect No response to DM4 request to control unit 68 Fog lamps (!) Steering angle sensor signal, implausible with regard to reference rate of turn No response to DM4 request to control unit 69 Fog lamps (!) Steering angle sensor, signal gradient No response to DM4 request to control unit 70 Tail light right Page 219 of 276

SPN 04071 04071 04071 04072 04072 04072 04073 04073 04073 04074 04074 04074

Control unit/System EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO

04075 04075 04075

EBS_5 TBM ZBRO

04076 04076 04076 04077 04077 04077 04078 04078 04078 04079 04079 04079 04080 04080 04080 04081 04081 04081 04082 04082 04082

EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO

04083 04083 04083

EBS_5 TBM ZBRO

04084 04084 04084

EBS_5 TBM ZBRO

04085 04085 04085 04086 04086 04086

EBS_5 TBM ZBRO EBS_5 TBM ZBRO

04087 04087 04087 04088 04088 04088

EBS_5 TBM ZBRO EBS_5 TBM ZBRO

SD 812a en-online 05.2007

Fault message (!) Steering angle sensor, sensor installed incorrectly No response to DM4 request to control unit 71 Tail light left ESP sensor supply No response to DM4 request to control unit 72 Side marker light 1 right Service brake module supply No response to DM4 request to control unit 73 Side marker light 1 left Pressure control module, outdated driver software No response to DM4 request to control unit 74 Side marker light 2 right Inconsistent driver software status between ECU and pressure control module No response to DM4 request to control unit 75 Side marker light 2 left Pressure control module, checksum error in external flash memory No response to DM4 request to control unit 76 Side marker light 3 right Pressure control module, installed but not configured No response to DM4 request to control unit 77 Side marker light 3 left Trailer control module - intake valve No response to DM4 request to control unit 78 Side marker light 4 right Trailer control module - exhaust valve No response to DM4 request to control unit 79 Side marker light 4 left Trailer control module: Check valve No response to DM4 request to control unit 80 Side marker light 5 right Trailer control module - pressure sensor supply No response to DM4 request to control unit 81 Side marker light 5 left Trailer control module No response to DM4 request to control unit 82 Side marker light 6 right Trailer control module, short circuit between intake and exhaust valves No response to DM4 request to control unit 83 Side marker light 6 left Trailer control module, short circuit between check and intake valves No response to DM4 request to control unit 84 Side marker light 7 right Trailer control module, short circuit between check and exhaust valves No response to DM4 request to control unit 85 Side marker light 7 left (!) Wheel sensor wheel 7 No response to DM4 request to control unit 86 Side marker light 8 right Wheel sensor wheel 7: Connection cable damaged or sensor defective No response to DM4 request to control unit 87 Side marker light 8 left (!) Wheel sensor wheel 8 No response to DM4 request to control unit 88 Parking light right Page 220 of 276

SPN

Control unit/System

04089 04089 04089 04090 04090 04090 04091 04091 04091

EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO

04092 04092 04092 04093 04093 04093

EBS_5 TBM ZBRO EBS_5 TBM ZBRO

04094 04094 04094

EBS_5 TBM ZBRO

04095 04095 04095

EBS_5 TBM ZBRO

04096 04096 04096

EBS_5 TBM ZBRO

04097 04097 04097

EBS_5 TBM ZBRO

04098 04098 04098

EBS_5 TBM ZBRO

04099 04099

EBS_5 TBM

04100 04100 04100

EBS_5 TBM ZBR2

04101 04101 04101 04101

EBS_5 EMOS TBM ZBR2

04102 04102 04102 04102

EBS_5 EMOS TBM ZBR2

04103 04103 04103 04103

EBS_5 EMOS TBM ZBR2

SD 812a en-online 05.2007

Fault message Wheel sensor wheel 8: Connection cable damaged or sensor defective No response to DM4 request to control unit 89 Parking light left Brake pad wear connection wheel 1 No response to DM4 request to control unit 90 Outline light rear right Brake pad wear sensor signal wheel 7 No response to DM4 request to control unit 91 Outline light rear left Brake pad wear sensor wheel 7: Difference between the 2 signals on the left and right sides of the axle too great No response to DM4 request to control unit 92 Outline light front right Brake pad wear sensor signal wheel 8 No response to DM4 request to control unit 93 Outline light front left Brake pad wear sensor wheel 8: Difference between the 2 signals on the left and right sides of the axle too great No response to DM4 request to control unit 94 Turn indicator check Pressure module control unit on wheel 1, incompatible software components No response to DM4 request to control unit 95 Turn indicator check trailer Pressure module control unit on wheel 1, fault in electronic circuit No response to DM4 request to control unit 96 Parking light 1 (tl. 58 for body builder) Pressure module control unit on wheel 1, internal control unit test incorrect No response to DM4 request to control unit 97 Parking light 2 (tl. 58 for body builder) Pressure module control unit on wheel 1, unknown pressure control module fault code No response to DM4 request to control unit 98 Reversing light trailer Pressure module control unit on wheel 1, incorrect system monitoring after activation No response to DM4 request to control unit 99 Pressure module control unit on wheel 2, incompatible software components No response to DM4 request to control unit 100 Headlight low beam, snowplough and gritter operation, right Pressure module control unit on wheel 2, fault in electronic circuit Gearshift sensor position No response to DM4 request to control unit 101 Headlight low beam, snowplough and gritter operation, left Pressure module control unit on wheel 2, internal control unit test incorrect Selection sensor position No response to DM4 request to control unit 102 Headlight high beam, snowplough and gritter operation, right Pressure module control unit on wheel 2, unknown pressure control module fault code Engine signal No response to DM4 request to control unit 103 Headlight high beam, snowplough and gritter operation, left Page 221 of 276

SPN

Control unit/System

04104 04104 04104

EBS_5 EMOS TBM

04104

ZBR2

04105 04105 04105

EBS_5 EMOS TBM

04105

ZBR2

04106 04106 04106 04106

EBS_5 EMOS TBM ZBRO

04107 04107 04107 04107

EBS_5 EMOS TBM ZBRO

04108 04108 04108 04108

EBS_5 EMOS TBM ZBRO

04109 04109 04109 04109

EBS_5 EMOS TBM ZBR2

04110 04110 04110 04110

EBS_5 EMOS TBM ZBRO

04111 04111 04111 04111

EBS_5 EMOS TBM ZBRO

04112 04112 04112 04112

EBS_5 EMOS TBM ZBRO

04113 04113 04113 04113

EBS_5 EMOS TBM ZBR2

04114 04114 04114 04114

EBS_5 EMOS TBM ZBRO

04115 04115

EBS_5 EMOS

SD 812a en-online 05.2007

Fault message Pressure module control unit on wheel 2, incorrect system monitoring after activation Gearbox pressure sensor signal No response to DM4 request to control unit 104 Current, parking light, tractive unit, snowplough and gritter operation, right Pressure module control unit on wheel 3, incompatible software components Selector lever information No response to DM4 request to control unit 105 Current, parking light, tractive unit, snowplough and gritter operation, left Pressure module control unit on wheel 3, fault in electronic circuit Request PTO1 signal No response to DM4 request to control unit 106 School bus lights check Pressure module control unit on wheel 3, internal control unit test incorrect Request PTO2 signal No response to DM4 request to control unit 107 School bus light left Pressure module control unit on wheel 3, unknown pressure control module fault code Coding PTO1 signal No response to DM4 request to control unit 108 School bus light right Pressure module control unit on wheel 3, incorrect system monitoring after activation Coding PTO2 signal No response to DM4 request to control unit 109 Switch, blackout light Pressure module control unit on wheel 4, incompatible software components PTO1 engaged signal No response to DM4 request to control unit 110 Fog lamps check Pressure module control unit on wheel 4, fault in electronic circuit PTO2 engaged signal No response to DM4 request to control unit 111 Side marker light 9 left Pressure module control unit on wheel 4, internal control unit test incorrect Timeout of EEC3 message No response to DM4 request to control unit 112 Side marker light 9 right Pressure module control unit on wheel 4, unknown pressure control module fault code Timeout Eng_Temp No response to DM4 request to control unit 113 Relay, parking lights right Pressure module control unit on wheel 4, incorrect system monitoring after activation Timeout of Amb_Cond message No response to DM4 request to control unit 114 Daytime driving lights Pressure module control unit on wheel 5, incompatible software components Timeout of ETC3 message Page 222 of 276

SPN 04115

Control unit/System TBM

04115

ZBR2

04116 04116 04116 04116

EBS_5 EMOS TBM ZBRO

04117 04117 04117 04117

EBS_5 EMOS TBM ZBRO

04118 04118 04118 04118

EBS_5 EMOS TBM ZBRO

04119

EBS_5

04119 04119 04119

EMOS TBM ZBR2

04120 04120 04120 04120

EBS_5 EMOS TBM ZBR2

04121

EBS_5

04121 04121 04121

EMOS TBM ZBR2

04122

EBS_5

04122 04122 04122

EMOS TBM ZBR2

04123 04123 04123 04123

EBS_5 EMOS TBM ZBR2

04124 04124 04124 04124

EBS_5 EMOS TBM ZBR2

04125 04125 04125 04125

EBS_5 EMOS TBM ZBR2

04126 04126 04126

EBS_5 EMOS TBM

SD 812a en-online 05.2007

Fault message No response to DM4 request to control unit 115 Number of height sensors RA set in parameters is incorrect (in ALW) Pressure module control unit on wheel 5, fault in electronic circuit Send queue overrun No response to DM4 request to control unit 116 Light test active Pressure module control unit on wheel 5, internal control unit test incorrect Send error of ETC1 message No response to DM4 request to control unit 117 Light test cancel Pressure module control unit on wheel 5, unknown pressure control module fault code Error warning vehicle CAN No response to DM4 request to control unit 118 Light test end Pressure module control unit on wheel 5, incorrect system monitoring after activation Implausibility between clutch position and clutch activations performed No response to DM4 request to control unit 119 Left turning light Pressure module control unit on wheel 6, incompatible software components Timeout of KSM1 message No response to DM4 request to control unit 120 Right turning light Pressure module control unit on wheel 6, fault in electronic circuit Checksum error when reading out data from EEPROM on ECU start No response to DM4 request to control unit 121 Left daytime driving light Pressure module control unit on wheel 6, internal control unit test incorrect Electrical power supply of gearshift and selection sensor: Value range exceeded No response to DM4 request to control unit 122 Right daytime driving light Pressure module control unit on wheel 6, unknown pressure control module fault code Clutch biting point cannot be ascertained No response to DM4 request to control unit 123 Daytime driving light switch Pressure module control unit on wheel 6, incorrect system monitoring after activation Gear disengagement No response to DM4 request to control unit 124 Light on alarm start Pressure module control unit on wheel 1, EEPROM data record is not compatible with the system Gate selection in gear engagement No response to DM4 request to control unit 125 Light switch power supply Pressure module control unit on wheel 1, EEPROM cannot be written Gear selection procedure No response to DM4 request to control unit 126 Page 223 of 276

SPN 04126

Control unit/System ZBR2

04127 04127 04127

EBS_5 EMOS TBM

04128 04128 04128

EBS_5 EMOS TBM

04129 04129 04129

EBS_5 EMOS TBM

04130 04130 04130

EBS_5 EMOS TBM

04131 04131 04131

EBS_5 EMOS TBM

04132 04132 04132

EBS_5 EMOS TBM

04133 04133 04133

EBS_5 EMOS TBM

04134

EBS_5

04134 04134

EMOS TBM

04135

EBS_5

04135 04135

EMOS TBM

04136

EBS_5

04136 04136

EMOS TBM

04137 04137 04137 04138 04138 04138

EBS_5 EMOS TBM EBS_5 EMOS TBM

04139 04139 04139

EBS_5 EMOS TBM

04140 04140 04140

EBS_5 EMOS TBM

SD 812a en-online 05.2007

Fault message Side marker light left or right Pressure module control unit on wheel 2, EEPROM data record is not compatible with the system Gear synchronisation No response to DM4 request to control unit 127 Pressure module control unit on wheel 2, EEPROM cannot be written Gear engagement No response to DM4 request to control unit 128 Pressure module control unit on wheel 3, EEPROM data record is not compatible with the system Timeout of ERC1_RX message No response to DM4 request to control unit 129 Pressure module control unit on wheel 3, EEPROM cannot be written Float switch signals Pentosin level too low No response to DM4 request to control unit 130 Pressure module control unit on wheel 4, EEPROM data record is not compatible with the system Gearshift sensor temperature No response to DM4 request to control unit 131 Pressure module control unit on wheel 4, EEPROM cannot be written Selection sensor temperature No response to DM4 request to control unit 132 Pressure module control unit on wheel 5, EEPROM data record is not compatible with the system Timeout of PROP_A message No response to DM4 request to control unit 133 Pressure module control unit on wheel 5, EEPROM cannot be written Tear-off or undervoltage of VPHS (TL 30-1). Pump inoperative or only operable with restrictions. No response to DM4 request to control unit 134 Pressure module control unit on wheel 6, EEPROM data record is not compatible with the system Tear-off or undervoltage of VP (TL 30-2). Redundant power supply is no longer available. No response to DM4 request to control unit 135 Pressure module control unit on wheel 6, EEPROM cannot be written Tear-off or excessive voltage drop of VMHS (TL 31-1). ECU power supply via VM (TL 31-2). Pump inoperative or only operable with restrictions. No response to DM4 request to control unit 136 Power supply pressure module on wheel 1, short circuit to terminal 15 Clutch venting not successful No response to DM4 request to control unit 137 Power supply pressure module on wheel 1 Main shut-off relay 1 No response to DM4 request to control unit 138 Power supply pressure module on wheel 1, short circuit between the connection cables Main switch-off relay 1 discontinuity No response to DM4 request to control unit 139 Power supply pressure module on wheel 2, short circuit to terminal 15 Main shut-off relay 2 No response to DM4 request to control unit 140 Page 224 of 276

SPN 04141 04141 04141

Control unit/System EBS_5 EMOS TBM

04142 04142 04142

EBS_5 EMOS TBM

04143 04143 04143 04144 04144 04144

EBS_5 EMOS TBM EBS_5 EMOS TBM

04145 04145 04145

EBS_5 EMOS TBM

04146 04146 04146 04147 04147 04147

EBS_5 EMOS TBM EBS_5 EMOS TBM

04148 04148 04148

EBS_5 EMOS TBM

04149 04149 04149 04150 04150 04150

EBS_5 EMOS TBM EBS_5 EMOS TBM

04151 04151 04151

EBS_5 EMOS TBM

04152 04152 04152 04153 04153 04153

EBS_5 EMOS TBM EBS_5 EMOS TBM

04154 04154 04155 04155 04156 04156 04157 04157 04157 04158 04158 04158

EBS_5 TBM EBS_5 TBM EBS_5 TBM EBS_5 EMOS TBM EBS_5 EMOS TBM

SD 812a en-online 05.2007

Fault message Power supply pressure module on wheel 2 Main switch-off relay 2 discontinuity No response to DM4 request to control unit 141 Power supply pressure module on wheel 2, short circuit between the connection cables Clutch opening valve 1 No response to DM4 request to control unit 142 Power supply pressure module on wheel 3, short circuit to terminal 15 Clutch engagement valve 1 No response to DM4 request to control unit 143 Power supply pressure module on wheel 3 Selection valve positive No response to DM4 request to control unit 144 Power supply pressure module on wheel 3, short circuit between the connection cables Selection valve negative No response to DM4 request to control unit 145 Power supply pressure module on wheel 4, short circuit to terminal 15 Gearshift pressure modulation valve No response to DM4 request to control unit 146 Power supply pressure module on wheel 4 Gearshift direction solenoid valve positive No response to DM4 request to control unit 147 Power supply pressure module on wheel 4, short circuit between the connection cables Gearshift direction solenoid valve negative No response to DM4 request to control unit 148 Power supply pressure module on wheel 5, short circuit to terminal 15 Clutch opening valve 2 No response to DM4 request to control unit 149 Power supply pressure module on wheel 5 Clutch engagement valve 2 No response to DM4 request to control unit 150 Power supply pressure module on wheel 5, short circuit between the connection cables Analogue/digital earth power current supply No response to DM4 request to control unit 151 Power supply pressure module on wheel 6, short circuit to terminal 15 Analogue/digital earth power current supply No response to DM4 request to control unit 152 Power supply pressure module on wheel 6 Analogue/digital earth power current supply No response to DM4 request to control unit 153 Power supply pressure module on wheel 6, short circuit between the connection cables No response to DM4 request to control unit 154 CAN signal brake on wheel 1 No response to DM4 request to control unit 155 CAN signal brake on wheel 2 No response to DM4 request to control unit 156 CAN signal brake on wheel 3 Digital output earth for activating e-components, pin X1/3 No response to DM4 request to control unit 157 CAN signal brake on wheel 4 Digital output earth for activating e-components, pin X1/3 No response to DM4 request to control unit 158 Page 225 of 276

SPN 04159 04159 04159 04160 04160 04160 04161 04161 04161 04162 04162 04162 04163

Control unit/System EBS_5 EMOS TBM EBS_5 EMOS TBM EBS_5 EMOS TBM EBS_5 EMOS TBM EBS_5

04163 04163 04164

EMOS TBM EBS_5

Selection actuator system switch-off because on-time exceeded No response to DM4 request to control unit 163 CAN signal brake on wheel 1, time overrun of message 14

04164 04164 04165 04165 04165 04166 04166 04166 04167 04167 04167 04168 04168 04168 04169 04169 04170

EMOS TBM EBS_5 EMOS TBM EBS_5 EMOS TBM EBS_5 EMOS TBM EBS_5 EMOS TBM EBS_5 TBM EBS_5

Gearshift actuator system switch-off because on-time exceeded No response to DM4 request to control unit 164 CAN signal brake on wheel 1, time overrun of message 21 On-time exceeded for selection actuator system No response to DM4 request to control unit 165 CAN signal brake on wheel 1, time overrun of message 22 On-time exceeded for engagement actuator system No response to DM4 request to control unit 166 CAN signal brake on wheel 1, time overrun of message 23 On-time exceeded for hydraulic pump No response to DM4 request to control unit 167 CAN signal brake on wheel 1, time overrun of message 24 Temperature below permitted limit value No response to DM4 request to control unit 168 CAN signal brake on wheel 2, time overrun of message 11 No response to DM4 request to control unit 169 CAN signal brake on wheel 2, time overrun of message 12

04170 04170 04171 04171 04171 04172 04172 04172 04173 04173 04174 04174 04174 04175 04175 04175 04176 04176 04176 04177 04177 04178 04178 04179

EMOS TBM EBS_5 EMOS TBM EBS_5 EMOS TBM EBS_5 TBM EBS_5 EMOS TBM EBS_5 EMOS TBM EBS_5 EMOS TBM EBS_5 TBM EBS_5 TBM EBS_5

Safety device (WDC/redundant shut-off path) does not function No response to DM4 request to control unit 170 CAN signal brake on wheel 2, time overrun of message 13 'Temperature sensor next to pump output stage' signal No response to DM4 request to control unit 171 CAN signal brake on wheel 2, time overrun of message 14 No pressure build-up possible during pump activation No response to DM4 request to control unit 172 CAN signal brake on wheel 2, time overrun of message 21 No response to DM4 request to control unit 173 CAN signal brake on wheel 2, time overrun of message 22 Vibrations on gearshift controller No response to DM4 request to control unit 174 CAN signal brake on wheel 2, time overrun of message 23 Vibrations on selection controller No response to DM4 request to control unit 175 CAN signal brake on wheel 2, time overrun of message 24 Vibrations on clutch controller No response to DM4 request to control unit 176 CAN signal brake on wheel 3, time overrun of message 11 No response to DM4 request to control unit 177 CAN signal brake on wheel 3, time overrun of message 12 No response to DM4 request to control unit 178 CAN signal brake on wheel 3, time overrun of message 13

SD 812a en-online 05.2007

Fault message CAN signal brake on wheel 5 Digital output earth for activating e-components, pin X1/3 No response to DM4 request to control unit 159 CAN signal brake on wheel 6 'Idling speed switch' signal or 'Kickdown active' signal No response to DM4 request to control unit 160 CAN signal brake on wheel 1, time overrun of message 11 Wheel differential speed signal No response to DM4 request to control unit 161 CAN signal brake on wheel 1, time overrun of message 12 Time information via CAN is not completely available No response to DM4 request to control unit 162 CAN signal brake on wheel 1, time overrun of message 13

Page 226 of 276

SPN 04179 04180

Control unit/System TBM EBS_5

04180 04180 04181 04181 04181 04182 04182 04182 04183 04183 04184 04184 04185 04185 04186 04186 04186 04187 04187 04188 04188 04189 04189 04190 04190 04191 04191 04192 04192 04193 04193 04194 04194 04195 04195 04196 04196 04197 04197 04198 04198 04199 04199 04200 04200 04200 04201 04201 04201 04202 04202 04202 04203 04203 04203 04204 04204

EMOS TBM EBS_5 EMOS TBM EBS_5 EMOS TBM EBS_5 TBM EBS_5 TBM EBS_5 TBM EBS_5 EMOS TBM EBS_5 TBM EBS_5 TBM EBS_5 TBM EBS_5 TBM EBS_5 TBM EBS_5 TBM EBS_5 TBM EBS_5 TBM EBS_5 TBM EBS_5 TBM EBS_5 TBM EBS_5 TBM EBS_5 TBM EBS_5 TBM ZBR2 EBS_5 TBM ZBR2 EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM

SD 812a en-online 05.2007

Fault message No response to DM4 request to control unit 179 CAN signal brake on wheel 3, time overrun of message 14 Sequence monitoring has detected error in function call sequence No response to DM4 request to control unit 180 CAN signal brake on wheel 3, time overrun of message 21 Security layer activated No response to DM4 request to control unit 181 CAN signal brake on wheel 3, time overrun of message 22 Engaged gear cannot be ascertained No response to DM4 request to control unit 182 CAN signal brake on wheel 3, time overrun of message 23 No response to DM4 request to control unit 183 CAN signal brake on wheel 3, time overrun of message 24 No response to DM4 request to control unit 184 CAN signal brake on wheel 4, time overrun of message 11 No response to DM4 request to control unit 185 CAN signal brake on wheel 4, time overrun of message 12 Vehicle speed signals No response to DM4 request to control unit 186 CAN signal brake on wheel 4, time overrun of message 13 No response to DM4 request to control unit 187 CAN signal brake on wheel 4, time overrun of message 14 No response to DM4 request to control unit 188 CAN signal brake on wheel 4, time overrun of message 21 No response to DM4 request to control unit 189 CAN signal brake on wheel 4, time overrun of message 22 No response to DM4 request to control unit 190 CAN signal brake on wheel 4, time overrun of message 23 No response to DM4 request to control unit 191 CAN signal brake on wheel 4, time overrun of message 24 No response to DM4 request to control unit 192 CAN signal brake on wheel 5, time overrun of message 11 No response to DM4 request to control unit 193 CAN signal brake on wheel 5, time overrun of message 12 No response to DM4 request to control unit 194 CAN signal brake on wheel 5, time overrun of message 13 No response to DM4 request to control unit 195 CAN signal brake on wheel 5, time overrun of message 14 No response to DM4 request to control unit 196 CAN signal brake on wheel 5, time overrun of message 21 No response to DM4 request to control unit 197 CAN signal brake on wheel 5, time overrun of message 22 No response to DM4 request to control unit 198 CAN signal brake on wheel 5, time overrun of message 23 No response to DM4 request to control unit 199 CAN signal brake on wheel 5, time overrun of message 24 No response to DM4 request to control unit 200 Entry light and interior lighting, right CAN signal brake on wheel 6, time overrun of message 11 No response to DM4 request to control unit 201 Entry light and interior lighting, left CAN signal brake on wheel 6, time overrun of message 12 No response to DM4 request to control unit 202 Interior lighting check CAN signal brake on wheel 6, time overrun of message 13 No response to DM4 request to control unit 203 Interior lighting 1 CAN signal brake on wheel 6, time overrun of message 14 No response to DM4 request to control unit 204 Page 227 of 276

SPN 04204 04205 04205 04205 04206 04206 04206 04207 04207 04207 04208 04208 04208

Control unit/System ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO

04209 04209 04209

EBS_5 TBM ZBRO

04210 04210 04210

EBS_5 TBM ZBRO

04211 04211 04211

EBS_5 TBM ZBRO

04212 04212 04212

EBS_5 TBM ZBRO

04213 04213 04213

EBS_5 TBM ZBRO

04214 04214 04214

EBS_5 TBM ZBRO

04215 04215 04215

EBS_5 TBM ZBRO

04216 04216 04216

EBS_5 TBM ZBRO

04217 04217 04217 04218 04218 04218 04219 04219 04219 04220 04220 04220 04221 04221

EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM

SD 812a en-online 05.2007

Fault message Interior lighting 1 continuous CAN signal brake on wheel 6, time overrun of message 21 No response to DM4 request to control unit 205 Interior lighting 1 economy CAN signal brake on wheel 6, time overrun of message 22 No response to DM4 request to control unit 206 Interior lighting 1 full CAN signal brake on wheel 6, time overrun of message 23 No response to DM4 request to control unit 207 Interior lighting 2 CAN signal brake on wheel 6, time overrun of message 24 No response to DM4 request to control unit 208 Interior lighting 2 continuous Speed sensor input on pressure regulating module wheel 1, faulty electronic circuit No response to DM4 request to control unit 209 Interior lighting 2 economy Speed sensor input on pressure regulating module wheel 2, faulty electronic circuit No response to DM4 request to control unit 210 Interior lighting 2 full Speed sensor input on pressure regulating module wheel 3, faulty electronic circuit No response to DM4 request to control unit 211 Interior lighting 2a continuous Speed sensor input on pressure regulating module wheel 4, faulty electronic circuit No response to DM4 request to control unit 212 Interior lighting 2a full Speed sensor input on pressure regulating module wheel 5, faulty electronic circuit No response to DM4 request to control unit 213 Interior lighting 2b continuous Speed sensor input on pressure regulating module wheel 6, faulty electronic circuit No response to DM4 request to control unit 214 Interior lighting 2b full Speed sensor input on pressure regulating module wheel 7, faulty electronic circuit No response to DM4 request to control unit 215 Interior lighting 3 Speed sensor input on pressure regulating module wheel 8, faulty electronic circuit No response to DM4 request to control unit 216 Interior lighting 3 Speed sensor input on pressure regulating module wheel 1, faulty electronic circuit No response to DM4 request to control unit 217 Interior lighting 3 check (!) Speed sensor wheel 2, air gap too great No response to DM4 request to control unit 218 Interior lighting 3 economy (!) Speed sensor wheel 3, air gap too great No response to DM4 request to control unit 219 Interior lighting 3 full (!) Speed sensor wheel 4, air gap too great No response to DM4 request to control unit 220 Night lighting (!) Speed sensor wheel 5, air gap too great No response to DM4 request to control unit 221 Page 228 of 276

SPN 04221 04222 04222 04222 04223 04223 04223 04224 04224 04224 04225 04225 04225 04226 04226 04226 04227 04227 04227 04228 04228 04228 04229 04229 04229 04230 04230 04230 04231 04231 04231 04232 04232 04232 04233 04233 04233 04234 04234 04234 04235 04235 04235 04236 04236 04236 04237 04237 04238 04238 04239 04239 04240 04240 04241 04241

Control unit/System ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBRO EBS_5 TBM ZBR2 EBS_5 TBM ZBR2 EBS_5 TBM EBS_5 TBM EBS_5 TBM EBS_5 TBM EBS_5 TBM

04242 04242

EBS_5 TBM

SD 812a en-online 05.2007

Fault message Night lighting (!) Speed sensor wheel 6, air gap too great No response to DM4 request to control unit 222 Night lighting check (!) Speed sensor wheel 7, air gap too great No response to DM4 request to control unit 223 Interior lighting 2c full (!) Speed sensor wheel 8, air gap too great No response to DM4 request to control unit 224 Interior lighting 1a full (!) Speed sensor wheel 1, impulse wheel defective No response to DM4 request to control unit 225 Interior lighting 1b full (!) Speed sensor wheel 2, impulse wheel defective No response to DM4 request to control unit 226 Interior lighting 1c full (!) Speed sensor wheel 3, impulse wheel defective No response to DM4 request to control unit 227 Interior lighting reduction (!) Speed sensor wheel 4, impulse wheel defective No response to DM4 request to control unit 228 Interior lighting reduct. check (!) Speed sensor wheel 5, impulse wheel defective No response to DM4 request to control unit 229 Footwell lighting (!) Speed sensor wheel 6, impulse wheel defective No response to DM4 request to control unit 230 Footwell lighting (!) Speed sensor wheel 7, impulse wheel defective No response to DM4 request to control unit 231 Aisle lighting (!) Speed sensor wheel 8, impulse wheel defective No response to DM4 request to control unit 232 Reading lights on (!) Speed sensor wheel 1, tyre diameter too great No response to DM4 request to control unit 233 Reading lights enable (!) Speed sensor wheel 2, tyre diameter too great No response to DM4 request to control unit 234 Interior lighting 4 (!) Speed sensor wheel 3, tyre diameter too great No response to DM4 request to control unit 235 Left entry lighting (!) Speed sensor wheel 4, tyre diameter too great No response to DM4 request to control unit 236 Right entry lighting (!) Speed sensor wheel 5, tyre diameter too great No response to DM4 request to control unit 237 (!) Speed sensor wheel 6, tyre diameter too great No response to DM4 request to control unit 238 (!) Speed sensor wheel 7, tyre diameter too great No response to DM4 request to control unit 239 (!) Speed sensor wheel 8, tyre diameter too great No response to DM4 request to control unit 240 Pressure module intake valve on wheel 1 No response to DM4 request to control unit 241 Pressure module intake valve on wheel 1, valve cannot be switched and is opened No response to DM4 request to control unit 242 Page 229 of 276

SPN

Control unit/System

04243 04243 04244 04244

EBS_5 TBM EBS_5 TBM

04245 04245

EBS_5 TBM

04246 04246 04247 04247

EBS_5 TBM EBS_5 TBM

04248 04248

EBS_5 TBM

04249 04249 04250 04250

EBS_5 TBM EBS_5 TBM

04251 04251

EBS_5 TBM

04252 04252 04253 04253

EBS_5 TBM EBS_5 TBM

04254 04254

EBS_5 TBM

04255 04255 04256

EBS_5 TBM EBS_5

04257

EBS_5

04258 04259

EBS_5 EBS_5

04260

EBS_5

04261 04262

EBS_5 EBS_5

04263

EBS_5

04264 04265

EBS_5 EBS_5

04266

EBS_5

04267 04268

EBS_5 EBS_5

04269

EBS_5

04270

EBS_5

SD 812a en-online 05.2007

Fault message Pressure module intake valve on wheel 1, valve cannot be switched and is closed No response to DM4 request to control unit 243 Pressure module intake valve on wheel 2 No response to DM4 request to control unit 244 Pressure module intake valve on wheel 2, valve cannot be switched and is opened No response to DM4 request to control unit 245 Pressure module intake valve on wheel 2, valve cannot be switched and is closed No response to DM4 request to control unit 246 Pressure module intake valve on wheel 3 No response to DM4 request to control unit 247 Pressure module intake valve on wheel 3, valve cannot be switched and is opened No response to DM4 request to control unit 248 Pressure module intake valve on wheel 3, valve cannot be switched and is closed No response to DM4 request to control unit 249 Pressure module intake valve on wheel 4 No response to DM4 request to control unit 250 Pressure module intake valve on wheel 4, valve cannot be switched and is opened No response to DM4 request to control unit 251 Pressure module intake valve on wheel 4, valve cannot be switched and is closed No response to DM4 request to control unit 252 Pressure module intake valve on wheel 5 No response to DM4 request to control unit 253 Pressure module intake valve on wheel 5, valve cannot be switched and is opened No response to DM4 request to control unit 254 Pressure module intake valve on wheel 5, valve cannot be switched and is closed No response to DM4 request to control unit 255 Pressure module intake valve on wheel 6 Pressure module intake valve on wheel 6, valve cannot be switched and is opened Pressure module intake valve on wheel 6, valve cannot be switched and is closed Pressure module exhaust valve on wheel 1 Pressure module exhaust valve on wheel 1, valve cannot be switched and is opened Pressure module exhaust valve on wheel 1, valve cannot be switched and is closed Pressure module exhaust valve on wheel 2 Pressure module exhaust valve on wheel 2, valve cannot be switched and is opened Pressure module exhaust valve on wheel 2, valve cannot be switched and is closed Pressure module exhaust valve on wheel 3 Pressure module exhaust valve on wheel 3, valve cannot be switched and is opened Pressure module exhaust valve on wheel 3, valve cannot be switched and is closed Pressure module exhaust valve on wheel 4 Pressure module exhaust valve on wheel 4, valve cannot be switched and is opened Pressure module exhaust valve on wheel 4, valve cannot be switched and is closed Page 230 of 276

SPN 04271

Control unit/System EBS_5

04272

EBS_5

04273 04274

EBS_5 EBS_5

04275 04276

EBS_5 EBS_5

04277 04278

EBS_5 EBS_5

04279 04280

EBS_5 EBS_5

04281 04282

EBS_5 EBS_5

04283 04284

EBS_5 EBS_5

04285 04286

EBS_5 EBS_5

04287

EBS_5

04288 04289 04290

EBS_5 EBS_5 EBS_5

04291 04292

EBS_5 EBS_5

04294 04295

EBS_5 EBS_5

04297 04298

EBS_5 EBS_5

04300 04300 04301 04301 04301

EBS_5 ZBR2 EBS_5 ZBR2 ZBRO

04302 04302 04302

EBS_5 ZBR2 ZBRO

04303 04303 04304 04304 04304 04305 04306 04306 04307 04307

EBS_5 ZBR2 EBS_5 ZBR2 ZBRO ZBR2 EBS_5 ZBR2 EBS_5 ZBR2

SD 812a en-online 05.2007

Fault message Pressure module exhaust valve on wheel 5 Pressure module exhaust valve on wheel 5, valve cannot be switched and is opened Pressure module exhaust valve on wheel 5, valve cannot be switched and is closed Pressure module exhaust valve on wheel 6 Pressure module exhaust valve on wheel 6, valve cannot be switched and is opened Pressure module backup valve on wheel 1 Pressure module backup valve on wheel 1, valve cannot be switched and is closed Pressure module backup valve on wheel 2 Pressure module backup valve on wheel 2, valve cannot be switched and is closed Pressure module backup valve on wheel 3 Pressure module backup valve on wheel 3, valve cannot be switched and is closed Pressure module backup valve on wheel 4 Pressure module backup valve on wheel 4, valve cannot be switched and is closed Pressure module backup valve on wheel 5 Pressure module backup valve on wheel 5, valve cannot be switched and is closed Pressure module backup valve on wheel 6 Pressure module backup valve on wheel 6, valve cannot be switched and is closed Pressure module pressure sensor on wheel 1, offset learned by teach-in Pressure module pressure sensor on wheel 1, signal Frequent-stop brake check lamp Pressure module pressure sensor on wheel 2, offset learned by teach-in Pressure module pressure sensor on wheel 2, signal Pressure module pressure sensor on wheel 3, offset learned by teach-in Pressure module pressure sensor on wheel 3, signal Pressure module pressure sensor on wheel 4, offset learned by teach-in Pressure module pressure sensor on wheel 4, signal Pressure module pressure sensor on wheel 5, offset learned by teach-in is too high Fill level, cleaning water Pressure module pressure sensor on wheel 5, signal Washer pump Windscreen washers Pressure module pressure sensor on wheel 5, offset learned by teach-in is too low Intermittent wipe switch Windscreen wiper interval Pressure module pressure sensor on wheel 6, offset learned by teach-in CLK interval switch Pressure module pressure sensor on wheel 6, signal Windscreen washer button Windscreen washers Rain sensor signal Wheel 1: Brake performance monitoring Fill level, headlight cleaning system Wheel 2: Brake performance monitoring Pump, headlight cleaning system Page 231 of 276

SPN 04308 04308 04309 04309 04310 04310 04310 04311 04311 04311

Control unit/System EBS_5 ZBR2 EBS_5 ZBR2 EBS_5 ZBR2 ZBRO EBS_5 ZBR2 ZBRO

04312 04312

EBS_5 ZBR2

(!) Wheel 1 in conjunction with ABS logic: ABS is demanding insufficient brake pressure over an implausibly long time Wiper switch position

04313 04313

EBS_5 ZBRO

(!) Wheel 2 in conjunction with ABS logic: ABS is demanding insufficient brake pressure over an implausibly long time Windscreen wiper stage 1

04314 04314

EBS_5 ZBRO

(!) Wheel 3 in conjunction with ABS logic: ABS is demanding insufficient brake pressure over an implausibly long time Windscreen wiper stage 2

04315

EBS_5

(!) Wheel 4 in conjunction with ABS logic: ABS is demanding insufficient brake pressure over an implausibly long time

04316

EBS_5

(!) Wheel 5 in conjunction with ABS logic: ABS is demanding insufficient brake pressure over an implausibly long time

04317 04318 04319 04320 04321 04322 04323

EBS_5 EBS_5 EBS_5 EBS_5 EBS_5 EBS_5 EBS_5

04324

EBS_5

04325

EBS_5

04326

EBS_5

04327

EBS_5

04328

EBS_5

04329

EBS_5

04330

EBS_5

04331

EBS_5

04332

EBS_5

04333

EBS_5

04334

EBS_5

SD 812a en-online 05.2007

Fault message Wheel 3: Brake performance monitoring Wiper motor revolutions Wheel 4: Brake performance monitoring Wiper motor speed Wheel 5: Brake performance monitoring Wiper relay (spare relay, parking light) Windscreen wiper relay Wheel 6: Brake performance monitoring Wiper limit switch Windscreen wiper zero position

(!) Wheel 6 in conjunction with ABS logic: ABS is demanding insufficient brake pressure over an implausibly long time (!) Wheel 1 in conjunction with ABS logic: Wheel speed fault (!) Wheel 2 in conjunction with ABS logic: Wheel speed fault (!) Wheel 3 in conjunction with ABS logic: Wheel speed fault (!) Wheel 4 in conjunction with ABS logic: Wheel speed fault (!) Wheel 5 in conjunction with ABS logic: Wheel speed fault (!) Wheel 6 in conjunction with ABS logic: Wheel speed fault (!) Wheel 1 in conjunction with ABS logic: Change between active and inactive ABS intervention too fast (!) Wheel 2 in conjunction with ABS logic: Change between active and inactive ABS intervention too fast (!) Wheel 3 in conjunction with ABS logic: Change between active and inactive ABS intervention too fast (!) Wheel 4 in conjunction with ABS logic: Change between active and inactive ABS intervention too fast (!) Wheel 5 in conjunction with ABS logic: Change between active and inactive ABS intervention too fast (!) Wheel 6 in conjunction with ABS logic: Change between active and inactive ABS intervention too fast External sequential fault: External vehicle speed signal implausible External sequential fault: Time overrun or fault condition in communication with gearbox control unit on CAN (SA=0x03) External sequential fault: Time overrun or fault condition in communication with EAC control unit d on CAN (SA=0x30) External sequential fault: Time overrun or fault condition in communication with ECAS control unit on CAN (SA=0x2F) External sequential fault: Time overrun or fault condition in communication with central on-board computer on CAN (SA=0x21) Page 232 of 276

SPN

Control unit/System

04335

EBS_5

04336

EBS_5

04337

EBS_5

04338

EBS_5

04339

EBS_5

04340

EBS_5

04341

EBS_5

04342

EBS_5

04343

EBS_5

04344

EBS_5

04345

EBS_5

04346

EBS_5

04347

EBS_5

04348

EBS_5

04349

EBS_5

04350 04351

EBS_5 EBS_5

04352

EBS_5

04353

EBS_5

04354

EBS_5

04355

EBS_5

04356

EBS_5

SD 812a en-online 05.2007

Fault message External sequential fault: Time overrun in communication with trailer control unit 1 External sequential fault: Time overrun in communication with trailer control unit 2 (!) Trailer control module pressure control: Implausible intake valve actuation (!) Trailer control module pressure control: Residual pressure detected (!) Trailer control module pressure control: Implausibly high pressure at the end of braking and parking brake signal defective (!) Trailer control module pressure control: Implausibly high pressure at the end of braking and long actuation of the parking brake switch (!) Trailer control module pressure control: Implausibly high pressure at the end of braking and long actuation of the antijackknife brake valve (!) Trailer control module pressure control: Implausibly high pressure at the end of braking and parking brake switch and trailer brake switch not actuated (!) Trailer control module pressure control: Implausibly high pressure at the end of braking and parking brake signal defective (!) Trailer control module pressure control: Implausibly high pressure at the end of braking and long actuation of the parking brake switch (!) Trailer control module pressure control: Implausibly high pressure at the end of braking and long actuation of the antijackknife brake switch (!) Trailer control module pressure control: Implausibly high pressure at the end of braking and parking brake switch and trailer brake switch not actuated (!) Trailer control module pressure control: Implausibly high pressure in the exhaust valve actuation and parking brake signal defective (!) Trailer control module pressure control: Implausibly high pressure in the exhaust valve actuation and long actuation of the parking brake switch (!) Trailer control module pressure control: Implausibly high pressure in the exhaust valve actuation and long actuation of the valve-controlled trailer brake switch (!) Trailer control module pressure control: Implausibly high pressure in the exhaust valve actuation and parking brake switch and trailer brake switch not actuated J1939 (driveline CAN): Time overrun in EBC1-RX message (!) Pressure regulating module pressure control on wheel 1: Pressure comparison plausibility error: Request is greater than the measured pressure (!) Pressure regulating module pressure control on wheel 2: Pressure comparison plausibility error: Request is greater than the measured pressure (!) Pressure regulating module pressure control on wheel 3: Pressure comparison plausibility error: Request is greater than the measured pressure (!) Pressure regulating module pressure control on wheel 4: Pressure comparison plausibility error: Request is greater than the measured pressure (!) Pressure regulating module pressure control on wheel 5: Pressure comparison plausibility error: Request is greater than the measured pressure Page 233 of 276

SPN

Control unit/System

04357

EBS_5

04358

EBS_5

04359

EBS_5

04360

EBS_5

04361

EBS_5

04362

EBS_5

04363

EBS_5

04364

EBS_5

04365

EBS_5

04366

EBS_5

04367

EBS_5

04368

EBS_5

04369

EBS_5

04370

EBS_5

04371

EBS_5

04372

EBS_5

04373

EBS_5

04374

EBS_5

04375

EBS_5

04376

EBS_5

04377

EBS_5

04378

EBS_5

04379

EBS_5

SD 812a en-online 05.2007

Fault message (!) Pressure regulating module pressure control on wheel 6: Pressure comparison plausibility error: Request is greater than the measured pressure (!) Pressure regulating module pressure control on wheel 1: Pressure comparison plausibility error: Measured pressure is greater than request (!) Pressure regulating module pressure control on wheel 2: Pressure comparison plausibility error: Measured pressure is greater than request (!) Pressure regulating module pressure control on wheel 3: Pressure comparison plausibility error: Measured pressure is greater than request (!) Pressure regulating module pressure control on wheel 4: Pressure comparison plausibility error: Measured pressure is greater than request (!) Pressure regulating module pressure control on wheel 5: Pressure comparison plausibility error: Measured pressure is greater than request (!) Pressure regulating module pressure control on wheel 6: Pressure comparison plausibility error: Measured pressure is greater than request (!) Pressure regulating module pressure control on wheel 1: Full braking test (!) Pressure regulating module pressure control on wheel 2: Full braking test (!) Pressure regulating module pressure control on wheel 3: Full braking test (!) Pressure regulating module pressure control on wheel 4: Full braking test (!) Pressure regulating module pressure control on wheel 5: Full braking test (!) Pressure regulating module pressure control on wheel 6: Full braking test (!) Pressure regulating module pressure control on wheel 1: Nominal/actual comparison between pressure regulating module pressure and supply pressure (!) Pressure regulating module pressure control on wheel 2: Nominal/actual comparison between pressure regulating module pressure and supply pressure (!) Pressure regulating module pressure control on wheel 3: Nominal/actual comparison between pressure regulating module pressure and supply pressure (!) Pressure regulating module pressure control on wheel 4: Nominal/actual comparison between pressure regulating module pressure and supply pressure (!) Pressure regulating module pressure control on wheel 5: Nominal/actual comparison between pressure regulating module pressure and supply pressure (!) Pressure regulating module pressure control on wheel 6: Nominal/actual comparison between pressure regulating module pressure and supply pressure (!) Pressure regulating module pressure control on wheel 1: Temporary backup test (!) Pressure regulating module pressure control on wheel 2: Temporary backup test (!) Pressure regulating module pressure control on wheel 3: Temporary backup test (!) Pressure regulating module pressure control on wheel 4: Temporary backup test Page 234 of 276

SPN

Control unit/System

04380

EBS_5

04381

EBS_5

04382

EBS_5

04383

EBS_5

04384

EBS_5

04385

EBS_5

04386

EBS_5

04387

EBS_5

04388

EBS_5

04389

EBS_5

04390

EBS_5

04391

EBS_5

04392

EBS_5

04393

EBS_5

04394

EBS_5

04395

EBS_5

04396

EBS_5

04397

EBS_5

04398

EBS_5

04399

EBS_5

04400 04400

EBS_5 ZBR2

04401 04401

EBS_5 ZBR2

04402 04402

EBS_5 ZBR2

04403 04403

EBS_5 ZBR2

04404 04404

EBS_5 ZBRO

04405 04405

EBS_5 ZBRO

04406

EBS_5

SD 812a en-online 05.2007

Fault message (!) Pressure regulating module pressure control on wheel 5: Temporary backup test (!) Pressure regulating module pressure control on wheel 6: Temporary backup test (!) Pressure regulating module pressure control on wheel 1: Temporary brake test (!) Pressure regulating module pressure control on wheel 2: Temporary brake test (!) Pressure regulating module pressure control on wheel 3: Temporary brake test (!) Pressure regulating module pressure control on wheel 4: Temporary brake test (!) Pressure regulating module pressure control on wheel 5: Temporary brake test (!) Pressure regulating module pressure control on wheel 6: Temporary brake test (!) Pressure regulating module pressure control on wheel 1: Implausible pressure differential right/left (!) Pressure regulating module pressure control on wheel 2: Implausible pressure differential right/left (!) Pressure regulating module pressure control on wheel 3: Implausible pressure differential right/left (!) Pressure regulating module pressure control on wheel 4: Implausible pressure differential right/left (!) Pressure regulating module pressure control on wheel 5: Implausible pressure differential right/left (!) Pressure regulating module pressure control on wheel 6: Implausible pressure differential right/left (!) Pressure regulating module pressure control on wheel 1: Implausible pressure when no braked applied (!) Pressure regulating module pressure control on wheel 2: Implausible pressure when no braked applied (!) Pressure regulating module pressure control on wheel 3: Implausible pressure when no braked applied (!) Pressure regulating module pressure control on wheel 4: Implausible pressure when no braked applied (!) Pressure regulating module pressure control on wheel 5: Implausible pressure when no braked applied (!) Pressure regulating module pressure control on wheel 6: Implausible pressure when no braked applied (!) Pressure regulating module pressure control on wheel 1: Implausible pressure at end of braking Grease quantity, central lubrication system (!) Pressure regulating module pressure control on wheel 2: Implausible pressure at end of braking Motor, central lubrication system (!) Pressure regulating module pressure control on wheel 3: Implausible pressure at end of braking Pump strokes, central lubrication system (!) Pressure regulating module pressure control on wheel 4: Implausible pressure at end of braking Interim lubrication button (!) Pressure regulating module pressure control on wheel 5: Implausible pressure at end of braking Central lubrication system (!) Pressure regulating module pressure control on wheel 6: Implausible pressure at end of braking Central lubrication system (!) Pressure regulating module pressure control on wheel 1: Implausible intake valve actuation Page 235 of 276

SPN

Control unit/System

04407

EBS_5

04408

EBS_5

04409

EBS_5

04410

EBS_5

04411

EBS_5

04412

EBS_5

04413

EBS_5

04414

EBS_5

04415

EBS_5

04416

EBS_5

04417

EBS_5

04418

EBS_5

04419

EBS_5

04420

EBS_5

04421

EBS_5

04422

EBS_5

04423 04424 04425 04426

EBS_5 EBS_5 EBS_5 EBS_5

04427 04428

EBS_5 EBS_5

04429 04430 04431 04432

EBS_5 EBS_5 EBS_5 ACC

04432 04433

EBS_5 ACC

04433

EBS_5

04434 04434 04435

ACC EBS_5 ACC

04435 04436

EBS_5 ACC

04436 04437

EBS_5 ACC

SD 812a en-online 05.2007

Fault message (!) Pressure regulating module pressure control on wheel 2: Implausible intake valve actuation (!) Pressure regulating module pressure control on wheel 3: Implausible intake valve actuation (!) Pressure regulating module pressure control on wheel 4: Implausible intake valve actuation (!) Pressure regulating module pressure control on wheel 5: Implausible intake valve actuation (!) Pressure regulating module pressure control on wheel 6: Implausible intake valve actuation (!) Pressure regulating module pressure control on wheel 1: Implausible exhaust valve actuation (!) Pressure regulating module pressure control on wheel 2: Implausible exhaust valve actuation (!) Pressure regulating module pressure control on wheel 3: Implausible exhaust valve actuation (!) Pressure regulating module pressure control on wheel 4: Implausible exhaust valve actuation (!) Pressure regulating module pressure control on wheel 5: Implausible exhaust valve actuation (!) Pressure regulating module pressure control on wheel 6: Implausible exhaust valve actuation (!) Pressure regulating module pressure control on wheel 1: Residual pressure detected (!) Pressure regulating module pressure control on wheel 2: Residual pressure detected (!) Pressure regulating module pressure control on wheel 3: Residual pressure detected (!) Pressure regulating module pressure control on wheel 4: Residual pressure detected (!) Pressure regulating module pressure control on wheel 5: Residual pressure detected (!) Pressure regulating module pressure control on wheel 6: Residual pressure detected (!) Yaw angle sensor: Standstill calibration failed (!) Yaw angle sensor: Long-time calibration failed (!) Yaw angle sensor: Fine tuning failed (!) Yaw angle sensor: Implausible signal (outside the validity range of the physical model) (!) Yaw angle sensor: Signal gradient too high (!) Yaw angle sensor: Implausible sensor signal in relation to reference yaw angle (!) Yaw angle sensor: Static self-check failed (!) Yaw angle sensor: Dynamic self-check failed Cruise control switch (sleeve) operated (!) Transverse acceleration sensor: Standstill calibration failed Cruise control switch 'Off' operated (!) Central control unit B-controller: ABS reference pressure implausible Driving speed limiter mode / driving speed limiter switch is on (!) ABS logic: Implausible activation time Parking brake not released/parking brake applied Pressure module control unit on wheel 1, inconsistent driver software version between ECU and boot loader ABS defective/invalid Pressure module control unit on wheel 1, checksum error in external flash memory EBS defective/invalid Page 236 of 276

SPN

Control unit/System

04437 04438

EBS_5 ACC

04438 04439

EBS_5 ACC

04439 04440

EBS_5 ACC

04440 04441

EBS_5 ACC

04441 04442

EBS_5 ACC

04442 04443

EBS_5 ACC

04443 04444

EBS_5 ACC

04444 04445

EBS_5 ACC

04445 04446

EBS_5 ACC

04446 04447

EBS_5 ACC

04447 04448

EBS_5 ACC

04448 04449

EBS_5 ACC

04449 04450

EBS_5 ACC

04450 04451

EBS_5 ACC

04451

EBS_5

04452

ACC

04452 04453

EBS_5 ACC

04453

EBS_5

04454

ACC

04454 04455

EBS_5 ACC

04455

EBS_5

SD 812a en-online 05.2007

Fault message Pressure module control unit on wheel 1, outdated driver software Pedal brake pressed Pressure module control unit on wheel 2, inconsistent driver software version between ECU and boot loader Sustained-action brake lever operated Pressure module control unit on wheel 2, checksum error in external flash memory Sustained-action brakes 'Off' Pressure module control unit on wheel 2, outdated driver software ASR intervention Pressure module control unit on wheel 3, inconsistent driver software version between ECU and boot loader ABS intervention Pressure module control unit on wheel 3, checksum error in external flash memory ESP intervention Pressure module control unit on wheel 3, outdated driver software ACC has activated EBS for too long / brake temperature Pressure module control unit on wheel 4, inconsistent driver software version between ECU and boot loader Engine speed too low Pressure module control unit on wheel 4, checksum error in external flash memory Delay too long Pressure module control unit on wheel 4, outdated driver software No/invalid road speed Pressure module control unit on wheel 5, inconsistent driver software version between ECU and boot loader No EBS intervention possible Pressure module control unit on wheel 5, checksum error in external flash memory EBS status check Pressure module control unit on wheel 5, outdated driver software ESP defective Pressure module control unit on wheel 6, inconsistent driver software version between ECU and boot loader No brake pedal / invalid CAN message EBC1.Brake pedal Pressure module control unit on wheel 6, checksum error in external flash memory Sustained-action brake lever defective / invalid CAN message ERC1X.Sustained-action brake lever Pressure module control unit on wheel 6, outdated driver software No engine / invalid CAN message EEC1.Torque Central control unit - B-controller: Configured service brake module characteristic has exceeded range Engine intervention not by ACC, driver, gearbox, HGB, FGB, EDR or brake (!) Central control unit - B-controller: Implausibly large difference between the deceleration requirements calculated by both controllers No engine revs / invalid CAN message EEC1.Engine revs Central control unit - B-controller critical: Variable range overrun or invalid function call Page 237 of 276

SPN

Control unit/System

04456

ACC

04456

EBS_5

04457

ACC

04457

EBS_5

04458 04458

ACC EBS_5

04459

ACC

04459

EBS_5

04460

ACC

04460 04461

EBS_5 ACC

04461 04462

EBS_5 ACC

04462 04463

EBS_5 ACC

04463

EBS_5

04464

ACC

04464

EBS_5

04465

ACC

04465

EBS_5

04466

ACC

04466

EBS_5

04467

ACC

04467

EBS_5

04468

ACC

04468

EBS_5

04469

ACC

04469

EBS_5

04470

ACC

04470 04471

EBS_5 ACC

04471

EBS_5

SD 812a en-online 05.2007

Fault message No accelerator pedal / invalid CAN message EEC2.Accelerator pedal Central control unit - B-controller critical: Checksum error in boot loader software No accelerator pedal / invalid CAN message EEC2.Idling speed switch Central control unit B-controller critical: Checksum error in external flash memory No RX / Invalid CAN message ERC1_RX. Torques (engine brake) Central control unit B-controller critical: RAM check failed No RD / Invalid CAN message ERC1_RD. Torques (secondary retarder) Central control unit B-controller critical: Arithmetic comparison test in microcontroller failed No RE / Invalid CAN message ERC1_RE. Torques (primary retarder) Central control unit B-controller critical: Stack memory overrun Retarder intervention fault Central control unit B-controller critical: SWI instruction or watchdog or clock pulse generator or PLL defect or external interruption was activated No earth Central control unit B-controller critical: Internal microcontroller fault detected Display defective Central control unit B-controller critical: Internal control unit fault No cruise control switch / invalid CAN message CCVS.Cruise control switch Central control unit B-controller critical: Internal control unit fault Cruise control active in ACC mode / invalid CAN message CCVS.Enable == cruise control Central control unit B-controller critical: Internal control unit fault No driving speed limiter switch / invalid CAN message CCVS.Driving speed limiter switch Central control unit B-controller critical: Unused interrupt routine activated No OFF sustained-action brakes / invalid CAN message CCVS.IntelBremsKopl Pressure module control unit on wheel 7: Mismatch between control unit types of operating software and boot loader No cruise control lever / invalid CAN message CCVS.Off switch or CCVS.Lever Supply voltage brake pad wear sensor wheel 1: Short circuit to ground No distance selector switch / invalid CAN message AUX1_ZBR.Switch Supply voltage brake pad wear sensor wheel 2: Short circuit to ground Driveline fault / invalid CAN message ETC1.ShiftInProcess or ETC1.DrivelineEngaged Supply voltage brake pad wear sensor wheel 3: Short circuit to ground Clutch fault / invalid CAN message CCVS.Clutch Supply voltage brake pad wear sensor wheel 4: Short circuit to ground Page 238 of 276

SPN 04472

Control unit/System ACC

04472

EBS_5

04473

ACC

04473 04474

EBS_5 ACC

04474 04475

EBS_5 ACC

04475 04476

EBS_5 ACC

Speed irregularities between EEC1.Engine revs and TCO1.Revs Supply voltage brake pad wear sensor wheel 6: Short circuit to ground Valid ETC2.Ratio markedly different from valid speed ratio Supply voltage brake pad wear sensor wheel 7: Short circuit to ground No TCO speed / invalid CAN message TCO.Speed Supply voltage brake pad wear sensor wheel 8: Short circuit to ground No wheel speed / invalid CAN message EBC2.Speed

04476 04477

EBS_5 ACC

Supply voltage brake pad wear sensor wheel 1: was deactivated Engine speed too high

04477 04478

EBS_5 ACC

Supply voltage brake pad wear sensor wheel 2: was deactivated No gear or clutch disengaged / open driveline for about 10 s

04478 04479

EBS_5 ACC

Supply voltage brake pad wear sensor wheel 3: was deactivated Speed too slow

04479 04480

EBS_5 ACC

Supply voltage brake pad wear sensor wheel 4: was deactivated Speed too fast

04480 04481

EBS_5 ACC

Supply voltage brake pad wear sensor wheel 5: was deactivated Bend too tight / valid bending too great

04481 04482

EBS_5 ACC

Supply voltage brake pad wear sensor wheel 6: was deactivated No / invalid yaw rate

04482 04483

EBS_5 ACC

Supply voltage brake pad wear sensor wheel 7: was deactivated No / invalid transverse acceleration

04483

EBS_5

Supply voltage brake pad wear sensor wheel 8: was deactivated

04484

ACC

04484 04485 04485

EBS_5 ACC EBS_5

04486

EBS_5

04487 04488 04489

EBS_5 EBS_5 EBS_5

04490

EBS_5

04491

EBS_5

04492

EBS_5

04493

EBS_5

04494

EBS_5

Radar still in initialisation mode (after ACC initialisation mode) (!) Trailer control module pressure control: Control piston (42) is defective Bending is detected as invalid in CAN message (!) Wheel sensor: Speed comparison Differential lock valve (differential lock switch): Installed component but not configured ESP sensor voltage supply: Faulty electronic circuit in EBS control unit Central control unit B-controller: Cannot be switched OFF Central control unit A-controller: internal calculation error J1939 (driveline CAN): Time overrun or fault condition in communication with ACC control unit on CAN (SA=0x2A) Central control unit A-controller: Mismatch between control unit types of operating software and boot loader Pressure module supply cable to wheel 1: Current magnitude too high Pressure module supply cable to wheel 2: Current magnitude too high Brake pad wear sensor wheel 1: Monitoring of brake pad wear signal (decreasing) between the axles of the vehicle

SD 812a en-online 05.2007

Fault message Clutch travel invalid Supply voltage brake pad wear sensor wheel 5: Short circuit to ground

Page 239 of 276

SPN

Control unit/System

04495

EBS_5

04496

EBS_5

04497

EBS_5

04498 04499

EBS_5 ACC

04499 04500

EBS_5 ACC

04500

DIW5

04500 04500 04500 04501

EBS_5 ZBR2 ZBRO ACC

04501

DIW5

04501 04502 04502

EBS_5 ACC DIW5

04502 04502 04503

EBS_5 ZBR2 ACC

04503

DIW5

04503 04503 04504

EBS_5 ZBRO ACC

04504

DIW5

04504 04504 04505

EBS_5 ZBRO ACC

04505

DIW5

04505 04505 04506

EBS_5 ZBRO ACC

04506

DIW5

04506 04506 04507

EBS_5 ZBRO ACC

04507

DIW5

04507 04507 04508 04508

EBS_5 ZBRO ACC DIW5

SD 812a en-online 05.2007

Fault message Pressure module supply cable to wheel 3: Current magnitude too high Brake pad wear sensor wheel 2: Monitoring of brake pad wear signal (decreasing) between the axles of the vehicle Pressure module supply cable to wheel 4: Current magnitude too high Brake pad wear sensor wheel 3: Monitoring of brake pad wear signal (decreasing) between the axles of the vehicle ACC control unit is still in initialisation phase Pressure module supply cable to wheel 5: Current magnitude too high Internal system error, Trap NMI Engine speed acquisition (positive connection of the sensor or the sensor circuit) Brake pad wear sensor wheel 4: Monitoring of brake pad wear signal (decreasing) between the axles of the vehicle Steering/trailing axle/anti-jacknife protection Steering oil level too low Internal system error, Stack overflow Gearbox output speed acquisition (positive connection of the sensor or the sensor circuit) Pressure module supply cable to wheel 6: Current magnitude too high Internal system error, Stack underflow Turbine speed acquisition Brake pad wear sensor wheel 5: Monitoring of brake pad wear signal (decreasing) between the axles of the vehicle Power steering oil level circuit 2 Internal system error, Trap ILLBUS Turbine speed acquisition (positive connection of the sensor or the sensor circuit) Brake pad wear sensor wheel 6: Monitoring of brake pad wear signal (decreasing) between the axles of the vehicle Anti-jackknife protection damping Internal system error, Trap ILLINA Gear oil temperature acquisition (negative connection of the sensor or the sensor circuit) Brake pad wear sensor wheel 7: Monitoring of brake pad wear signal (decreasing) between the axles of the vehicle Anti-jackknife protection oil level too low Internal system error, Trap ILLOPA Gear oil temperature acquisition (positive connection of the sensor or the sensor circuit) Brake pad wear sensor wheel 8: Monitoring of brake pad wear signal (decreasing) between the axles of the vehicle Anti-jackknife protection oil level too low Internal system error, Trap PRTFLT Retarder oil temperature acquisition (negative connection of the sensor or the sensor circuit) Supply voltage trailer control module valve: Current magnitude too high Articulation damping button Internal system error, Trap UNDOPC Retarder oil temperature acquisition (positive connection of the sensor or the sensor circuit) Brake pad wear sensor wheel 1: Monitoring of brake pad wear signal (decreasing) within the axles Articulation angle > 48 degrees Internal system error, Trap PECC5 Solenoid valve supply voltage Page 240 of 276

SPN

Control unit/System

04508 04508 04509 04509

EBS_5 ZBRO ACC DIW5

04509 04509 04510

EBS_5 ZBRO ACC

04510

DIW5

04510 04510 04511

EBS_5 ZBRO ACC

04511

DIW5

04511 04511 04512

EBS_5 ZBRO ACC

04512

DIW5

04512 04512 04513

EBS_5 ZBRO ACC

04513

DIW5

04513 04513 04514

EBS_5 ZBRO ACC

04514

DIW5

04514 04514

EBS_5 ZBRO

04515

ACC

04515 04515 04516 04516 04517 04517 04517 04518

DIW5 ZBRO ACC ZBRO ACC EBS_5 ZBRO ACC

04518 04518 04519

EBS_5 ZBRO ACC

04519 04519

EBS_5 ZBRO

SD 812a en-online 05.2007

Fault message Brake pad wear sensor wheel 2: Monitoring of brake pad wear signal (decreasing) within the axles Steering oil level too low Internal system error, Trap PECC6 Central solenoid valve handler Brake pad wear sensor wheel 3: Monitoring of brake pad wear signal (decreasing) within the axles Steering adjustment enable Internal system error, Trap PECC7 Working coil of the EK solenoid valve (cabling between input clutch solenoid valve and the gearbox control unit) Brake pad wear sensor wheel 4: Monitoring of brake pad wear signal (decreasing) within the axles Brake lamp to steered trailing axle Internal RAM defective / memory test on switch-on Measuring coil of the EK solenoid valve (cabling between input clutch solenoid valve and the gearbox control unit) Brake pad wear sensor wheel 5: Monitoring of brake pad wear signal (decreasing) within the axles Bus-stop brake to steered trailing axle External RAM defective / address line test on switch-on Cabling between negative connection of the working coil of the EK (input clutch) solenoid valve and the gearbox control unit Brake pad wear sensor wheel 6: Monitoring of brake pad wear signal (decreasing) within the axles Engine running to steered trailing axle External RAM defective / memory test on switch-on Cabling between negative connection of the measuring coil of the EK (input clutch) solenoid valve and the gearbox control unit Brake pad wear sensor wheel 7: Monitoring of brake pad wear signal (decreasing) within the axles Steered trailing axle check yellow Flash defective / Flash checksum test on switch-on Cabling between positive connection of the working coil of the EK (input clutch) solenoid valve and the gearbox control unit Brake pad wear sensor wheel 8: Monitoring of brake pad wear signal (decreasing) within the axles Steered trailing axle check red External watchdog / Test of function of the external watchdog on switch-on Cabling between positive connection of the measuring coil of the EK (input clutch) solenoid valve and the gearbox control unit Steered trailing axle red STOP Program runtime exceeded Steered trailing axle check oil level HighLevelTask too long / runtime monitoring Central control unit - A-controller: Checksum error Steered trailing axle check oil level LowLevelTask too long / runtime monitoring Central control unit - A-controller: Incompatible software components Anti-jackknife protection bypass damping Application task too long Central control unit - A-controller: Checksum error in the boot loader software Steered trailing axle check yellow Page 241 of 276

SPN 04520

Control unit/System ACC

04520

DIW5

04520 04520 04521

EBS_5 ZBRO ACC

04521 04521 04521 04522

DIW5 EBS_5 ZBRO ACC

04522

DIW5

04522 04522 04523

EBS_5 ZBRO ACC

04523

DIW5

04523 04523 04524

EBS_5 ZBR2 ACC

04524

DIW5

04524 04524

EBS_5 ZBR2

04525

ACC

04525 04525 04526 04526 04526

DIW5 ZBRO ACC EBS_5 ZBRO

04527 04527 04527

ACC EBS_5 ZBRO

04528 04528 04528 04529 04529 04529 04530

ACC EBS_5 ZBRO ACC EBS_5 ZBRO ACC

04530

DIW5

04530 04530 04531

EBS_5 ZBRO ACC

SD 812a en-online 05.2007

Fault message Supply voltage (tl.15) too low Working coil of the DK solenoid valve (cabling between pressure clutch solenoid valve and the gearbox control unit) Central control unit - B-controller: Mismatch between control unit types of operating software and boot loader Steered trailing axle check red TL30 voltage too low Measuring coil of the DK solenoid valve (cabling between pressure clutch solenoid valve and the gearbox control unit) Central control unit - B-controller: Checksum error Steered trailing axle red STOP Relay defective, no TL30 Cabling between negative connection of the working coil of the DK (pressure clutch) solenoid valve and the gearbox control unit. Central control unit EEPROM: implausible values in configuration list Bus-stop brake automatic shut-off to steered trailing axle Relay defective, continuous TL30 Cabling between negative connection of the measuring coil of the DK (pressure clutch) solenoid valve and the gearbox control unit. Central control unit EEPROM: Checksum error in configuration list Steering oil pressure wheel-driven Invalid data record / EEPROM checksum test on switch-on Cabling between positive connection of the working coil of the DK (pressure clutch) solenoid valve and the gearbox control unit. Transverse acceleration sensor: EOL calibration not completed Steering oil pressure engine-driven Driveline Can error / if Bus-Off is reached and 0.5 s afterwards. Cabling between positive connection of the measuring coil of the DK (pressure clutch) solenoid valve and the gearbox control unit. Articulation angle > 17 degrees Driveline Can error / if overflow occurred in CAN controller ISO 11992 (trailer CAN): CAN-Low line defective Anti-jackknife protection engine idling Cannot send TSC1-EBS / last send message has not been sent yet ISO 11992 (trailer CAN): CAN-High line defective Anti-jackknife protection torque reduction Cannot send TSC1-FFR / last send message has not been sent yet Brakes CAN: No communication Articulation button when driving forwards EBC1 CAN message not received Sensor CAN: No communication Articulation button in R gear/art. ang. > 48 deg. ERC1_RX CAN message not received (engine brake) Working coil of the SK solenoid valve (cabling between high range clutch solenoid valve and the gearbox control unit) Time overrun or implausible status in communication with the ACC control unit (SA=0x2A) Articulation angle < 17 degrees ERC1_RE CAN message not received (primary retarder) Page 242 of 276

SPN

Control unit/System

04531

DIW5

04531 04531 04532

EBS_5 ZBRO ACC

04532 04532 04533

DIW5 EBS_5 ACC

04533

DIW5

04533 04534

EBS_5 ACC

04534

DIW5

04534

EBS_5

04535

ACC

04535 04535 04536 04536 04537 04537 04538

DIW5 EBS_5 ACC EBS_5 ACC EBS_5 ACC

04538 04539

EBS_5 ACC

04539 04540

EBS_5 ACC

04540 04540 04541

DIW5 EBS_5 ACC

04541

DIW5

04541 04542

EBS_5 ACC

04542

DIW5

04542 04543

EBS_5 ACC

04543 04543

DIW5 EBS_5

SD 812a en-online 05.2007

Fault message Measuring coil of the SK solenoid valve (cabling between high range clutch solenoid valve and the gearbox control unit) Supply voltage for the EBS control unit: Range overrun or underrun (< 8.5 volts / > 36 volts) Steering column adjustment ERC1_RD CAN message not received (secondary retarder) Cabling between negative connection of the working coil of the SK (high range clutch) solenoid valve and the gearbox control unit. Yaw angle sensor: implausible values EEC1 CAN message not received Cabling between negative connection of the measuring coil of the SK (high range clutch) solenoid valve and the gearbox control unit. Supply voltage for pressure control valves and trailer control module: Range underrun when starting CCVS CAN message not received Cabling between positive connection of the working coil of the SK (high range clutch) solenoid valve and the gearbox control unit. Supply voltage for the modules: Range underrun when starting Not all control lever operations / CCVS (cruise control/vehicle speed) message cycle too fast Cabling between positive connection of the measuring coil of the SK (high range clutch) solenoid valve and the gearbox control unit. Supply voltage for the CAN: Range underrun when starting TCO1 CAN message not received Supply voltage for the ESP sensors: Range underrun EBC2 CAN message not received Supply voltage for the pressure module: Range underrun EEC2 CAN message not received Supply voltage for electronic pressure control of the pressure modules: Range underrun ETC1 CAN message not received Supply voltage for the pressure regulating valves: Range underrun ETC2 CAN message not received Working coil of the PB solenoid valve (cabling between pump brake solenoid valve and the gearbox control unit) Supply voltage for the additional valve: Range underrun TC1 CAN message not received Measuring coil of the PB solenoid valve (cabling between pump brake solenoid valve and the gearbox control unit) Supply voltage for the differential lock switch: Range underrun VDC1 CAN message not received Cabling between negative connection of the working coil of the PB (pump brake) solenoid valve and the gearbox control unit. Supply voltage for the trailer control module valves: Range underrun AUX1_ZBR CAN message not received Cabling between negative connection of the measuring coil of the PB (pump brake) solenoid valve and the gearbox control unit. Supply voltage for J1939 (driveline CAN): Range underrun Page 243 of 276

SPN

Control unit/System

04544

ACC

04544 04544

DIW5 EBS_5

Cabling between positive connection of the working coil of the PB (pump brake) solenoid valve and the gearbox control unit. Supply voltage for ISO 11992 (trailer CAN): Range underrun

04545

ACC

Cannot send DM1 / last send message has not been sent yet

04545 04545

DIW5 EBS_5

04546 04546 04547 04547 04548 04548

ACC EBS_5 ACC EBS_5 ACC EBS_5

04549 04549

ACC EBS_5

04550

ACC

04550

DIW5

04550 04551

EBS_5 ACC

04551

DIW5

04551

EBS_5

04552

ACC

04552 04552

DIW5 EBS_5

04553

ACC

04553

DIW5

04553

EBS_5

04554

ACC

04554

DIW5

04554

EBS_5

04555

ACC

04555

DIW5

SD 812a en-online 05.2007

Fault message Cannot send ACC1 / last send message has not been sent yet

Cabling between positive connection of the measuring coil of the PB (pump brake) solenoid valve and the gearbox control unit. Supply voltage for CAN brake: Range underrun Synchronisation error / TCO1 CAN messages not received in cycle ABS logic: Request red warning lamp WEIG CAN message not received System test: Invalid configuration ALB CAN message not received System test: Reconfiguration of pressure control module Cannot send Trans-Conf request / Cannot request Trans Config CAN message System test: Dynamometer test rig mode active No configuration messages / Trans,Rx,Rd,Re,Ccvs Config not received Working coil of the RBK solenoid valve (cabling between reverse gear brake solenoid valve small piston and the gearbox control unit) System test: Pressure regulating module voltage supply; short circuit to terminal 15 Eng-Conf CAN messages not received Measuring coil of the RBK solenoid valve (cabling between reverse gear brake small piston solenoid valve and the gearbox control unit) External sequential fault: External vehicle weight signal implausible (CAN message: vehicle weight) Check EBC1 timeout / Timeout was only detected by additional monitoring Cabling between negative connection of the working coil of the RBK (reverse gear brake small piston) solenoid valve and the gearbox control unit. External sequential fault: Trailer ABS is not fully functional Check brake / Excessive braking time only detected in additional monitoring Cabling between negative connection of the measuring coil of the RBK (reverse gear brake small piston) solenoid valve and the gearbox control unit. External sequential fault: External input is implausible for ESP Check TCO1 tachograph timeout / Timeout was only detected by additional monitoring Cabling between positive connection of the working coil of the RBK (reverse gear brake small piston) solenoid valve and the gearbox control unit. External sequential fault: External input is implausible for EBS functions Check delay / Excessively long delay was only detected in additional monitoring Cabling between positive connection of the measuring coil of the RBK (reverse gear brake small piston) solenoid valve and the gearbox control unit. Page 244 of 276

SPN

Control unit/System

04555 04556

EBS_5 ACC

04556 04557

EBS_5 ACC

04557 04558 04558 04559

EBS_5 ACC EBS_5 ACC

04559 04560

EBS_5 ACC

04560

DIW5

04560

EBS_5

04561

ACC

04561

DIW5

04561

EBS_5

04562

ACC

04562 04562 04563

DIW5 EBS_5 ACC

04563

DIW5

04563 04564

EBS_5 ACC

04564

DIW5

04564 04565

EBS_5 ACC

04565

DIW5

04565 04566 04566 04567

EBS_5 ACC EBS_5 ACC

04567 04568

EBS_5 ACC

04568 04569

EBS_5 ACC

04569 04570

EBS_5 ACC

SD 812a en-online 05.2007

Fault message Pressure module control unit on wheel 1: Axle load sensor electrical power supply is not switched on Sensor CAN fault / if Bus-Off is reached Pressure module control unit on wheel 1: Axle load sensor electrical power supply short circuit to terminal 30 SSTA not received Pressure module control unit on wheel 1: incorrect / inconsistent data record parameter in EEPROM STGT not received CAN signal brake on wheel 1: No communication STGT2 not received Pressure module control unit on wheel 2: Axle load sensor electrical power supply is not switched on Radar fault / internal radar fault Working coil of the TB solenoid valve (cabling between turbine brake solenoid valve and the gearbox control unit) Pressure module control unit on wheel 2: Axle load sensor electrical power supply short circuit to terminal 30 Radar fault / incorrect or irreparably damaged radar software (ERROR_SOFTWARE1) Measuring coil of the TB solenoid valve (cabling between turbine brake solenoid valve and the gearbox control unit) Pressure module control unit on wheel 2: incorrect / inconsistent data record parameter in EEPROM Radar fault / Incorrect or irreparably damaged radar software (ERROR_SOFTWARE2) Cabling between negative connection of the working coil of the TB (turbine brake) solenoid valve and the gearbox control unit. CAN signal brake on wheel 2: No communication Radar fault / supply voltage too high Cabling between negative connection of the measuring coil of the TB (turbine brake) solenoid valve and the gearbox control unit. Pressure module control unit on wheel 3: Axle load sensor electrical power supply is not switched on Radar fault / supply voltage too low Cabling between positive connection of the working coil of the TB (turbine brake) solenoid valve and the gearbox control unit. Pressure module control unit on wheel 3: Axle load sensor electrical power supply short circuit to terminal 30 Radar fault / TRM too hot Cabling between positive connection of the measuring coil of the TB (turbine brake) solenoid valve and the gearbox control unit. Pressure module control unit on wheel 3: incorrect / inconsistent data record parameter in EEPROM Radar fault / TRM too cold CAN signal brake on wheel 3: No communication Radar fault / PCM too hot Pressure module control unit on wheel 4: Axle load sensor electrical power supply is not switched on Radar fault / sensor CAN bus fault Pressure module control unit on wheel 4: Axle load sensor electrical power supply short circuit to terminal 30 Radar fault / sensor CAN message fault Pressure module control unit on wheel 4: incorrect / inconsistent data record parameter in EEPROM Radar fault / no parameter settings Page 245 of 276

SPN

Control unit/System

04570 04570 04571

DIW5 EBS_5 ACC

04571 04572

EBS_5 ACC

04572

DIW5

04572 04573

EBS_5 ACC

04573 04574

EBS_5 ACC

04574 04574 04575

DIW5 EBS_5 ACC

04575 04576

EBS_5 ACC

04576 04577

EBS_5 ACC

04577 04578 04578 04579

EBS_5 ACC EBS_5 ACC

04579 04580

EBS_5 ACC

04580

DIW5

04580 04581

EBS_5 ACC

04581

EBS_5

04582

ACC

04582 04582 04583

DIW5 EBS_5 ACC

04583 04584

EBS_5 ACC

04584

DIW5

04584 04585

EBS_5 ACC

04585

EBS_5

SD 812a en-online 05.2007

Fault message WP solenoid valve (cabling between converter pressure solenoid valve and the gearbox control unit) CAN signal brake on wheel 4: No communication Radar fault / pairing fault Pressure module control unit on wheel 5: Axle load sensor electrical power supply is not switched on Radar fault / HF switched off Cabling between negative connection of the working coil of the WP (converter pressure) solenoid valve and the gearbox control unit. Pressure module control unit on wheel 5: Axle load sensor electrical power supply short circuit to terminal 30 Radar fault / sensor alignment fault Pressure module control unit on wheel 5: incorrect / inconsistent data record parameter in EEPROM Radar fault / background noise fault Cabling between positive connection of the working coil of the WP (converter pressure) solenoid valve and the gearbox control unit. CAN signal brake on wheel 5: No communication Radar fault / aerial blocked Pressure module control unit on wheel 6: Axle load sensor electrical power supply is not switched on ESP gyro fault Pressure module control unit on wheel 6: Axle load sensor electrical power supply short circuit to terminal 30 Cannot send YRSContr. / last gyro request not sent Pressure module control unit on wheel 6: incorrect / inconsistent data record parameter in EEPROM Cannot receive YRSData / gyro message not received CAN signal brake on wheel 6: No communication YRS fault / internal gyro fault or wrong ID Pressure module control unit on wheel 7: Axle load sensor electrical power supply is not switched on Cannot send SVEH WR solenoid valve (cabling between converter pressure control solenoid valve and the gearbox control unit) Pressure module control unit on wheel 7: Axle load sensor electrical power supply short circuit to terminal 30 Yaw rates installation / Internal gyro installed incorrectly Pressure module control unit on wheel 7: incorrect / inconsistent data record parameter in EEPROM Transverse acceleration installation / Internal gyro installed incorrectly Cabling between negative connection of the working coil of the WR (converter pressure control) solenoid valve and the gearbox control unit. CAN signal brake on wheel 7: No communication User stack error Pressure module control unit on wheel 8: Axle load sensor electrical power supply is not switched on Piece AT fault Cabling between positive connection of the working coil of the WR (converter pressure control) solenoid valve and the gearbox control unit. Pressure module control unit on wheel 8: Axle load sensor electrical power supply short circuit to terminal 30 ACC status fault Pressure module control unit on wheel 8: incorrect / inconsistent data record parameter in EEPROM Page 246 of 276

SPN 04586 04586 04587 04588

Control unit/System ACC EBS_5 EBS_5 EBS_5

04589

EBS_5

04590 04590 04591 04591

DIW5 EBS_5 DIW5 EBS_5

04592 04592 04593

DIW5 EBS_5 EBS_5

04594 04594 04595

DIW5 EBS_5 EBS_5

04596

EBS_5

04597

EBS_5

04598 04599

EBS_5 DIW5

04599 04600

EBS_5 DIW5

04600 04600 04601

EBS_5 ZBR2 DIW5

04601 04601 04602

EBS_5 ZBR2 DIW5

04602 04602 04603

EBS_5 ZBRO DIW5

04603 04603

EBS_5 ZBRO

04604

DIW5

04604 04604 04605 04605 04605 04606 04606 04606 04607

EBS_5 ZBRO DIW5 EBS_5 ZBRO DIW5 EBS_5 ZBRO DIW5

SD 812a en-online 05.2007

Fault message EBC5 message not received (high resolution wheel speed) CAN signal brake on wheel 8: No communication Pedal brake module switch 1: internal control unit fault Central control unit - B-controller: internal control unit fault Central control unit - B-controller: Analog / digital converter comparison error RBG solenoid valve (cabling between reverse gear brake large piston solenoid valve and the gearbox control unit) Central control unit - B-controller: Incorrect function call Solenoid valve RBG Central control unit - B-controller: Self test comparison error Cabling between negative connection of the working coil of the RBG (reverse gear brake large piston) solenoid valve and the gearbox control unit. Central control unit - A-controller: internal control unit fault Central control unit - A-controller: Incorrect function call Cabling between positive connection of the working coil of the RBG (reverse gear brake large piston) solenoid valve and the gearbox control unit. Central control unit - A-controller: not switched on Central control unit EEPROM: incorrect configuration (!) Trailer control module pressure control: implausible pressure when no brake applied (!) Trailer control module pressure control: Backup test briefly incorrect (!) Central control unit - B-controller: implausibly high pressure from trailer control module sensor Gear oil level monitoring Brake pad wear sensor wheel 1: Difference between the 2 signals on the left and right sides of the axle too great Voith ambient condition Brake pad wear sensor wheel 2: Difference between the 2 signals on the left and right sides of the axle too great Door and stop symbol system Gearbox control unit Brake pad wear sensor wheel 3: Difference between the 2 signals on the left and right sides of the axle too great L.h. door contact Software in gearbox control unit Brake pad wear sensor wheel 4: Difference between the 2 signals on the left and right sides of the axle too great Request stop button enable Data record Brake pad wear sensor wheel 5: Difference between the 2 signals on the left and right sides of the axle too great Request stop button Gearbox mechanism / internal cause in gearbox (e.g. oil level, etc.) Brake pad wear sensor wheel 6: Difference between the 2 signals on the left and right sides of the axle too great Request stop button Incorrect control unit configuration Wheel 7: Brake performance monitoring Request stop display System fault electrical / electronic system Wheel 8: Brake performance monitoring Request stop by person with disability Data record gearbox control unit

Page 247 of 276

SPN

Control unit/System

04607 04607 04608

EBS_5 ZBRO DIW5

04608 04608 04609 04609 04609 04610 04610 04610

EBS_5 ZBRO DIW5 EBS_5 ZBRO DIW5 EBS_5 ZBRO

04611

DIW5

04611 04611 04612

EBS_5 ZBRO DIW5

04612 04612

EBS_5 ZBRO

04613 04613 04613

DIW5 EBS_5 ZBRO

04614

DIW5

04614 04614

EBS_5 ZBRO

04615 04615

EBS_5 ZBRO

04616 04616

EBS_5 ZBRO

04617 04617

EBS_5 ZBRO

04618 04618

EBS_5 ZBRO

04619 04619 04620

EBS_5 ZBRO DIW5

04620 04620 04621 04621 04621

EBS_5 ZBRO DIW5 EBS_5 ZBRO

04622 04622 04622 04623

DIW5 EBS_5 ZBRO DIW5

SD 812a en-online 05.2007

Fault message (!) Wheel 7 in conjunction with ABS logic: ABS is demanding insufficient brake pressure over an implausibly long time Baby carriage Combination gearbox and data record (!) Wheel 8 in conjunction with ABS logic: ABS is demanding insufficient brake pressure over an implausibly long time Baby carriage Identification data in the gearbox (TIM in the gearbox) (!) Wheel 7 in conjunction with ABS logic: Wheel speed fault Baby carriage message Cabling digital ABS (!) Wheel 8 in conjunction with ABS logic: Wheel speed fault Baby carriage message CAN message EBC1, continuously active ABS via the CAN signal (!) Wheel 7 in conjunction with ABS logic: Change between active and inactive ABS intervention too fast Cancel baby carriage Voith ambient condition (!) Wheel 8 in conjunction with ABS logic: Change between active and inactive ABS intervention too fast Cancel baby carriage CAN message EBC1: CAN signals, ABS fully operational/active Central control unit: Temperature too high Door 3 photoelectric barrier/sensor CAN message EBC1: ABS fully operational / ABS system is not OK. Wheel sensor wheel 1: Connection cable damaged or sensor defective Door 3 photoelectric barrier/sensor Wheel sensor wheel 2: Connection cable damaged or sensor defective Request stop buzzer Wheel sensor wheel 3: Connection cable damaged or sensor defective Fault value door system Wheel sensor wheel 4: Connection cable damaged or sensor defective Request for bus-stop brake by MTS Wheel sensor wheel 5: Connection cable damaged or sensor defective Door icing Wheel sensor wheel 6: Connection cable damaged or sensor defective Red/green display door system Digital input signal for shift program selection (SP-SEL) Output from additional valve: Short circuit between the connection cables Stop lamp MTS Digital input signal for automatic neutral shift (ANS) Output from additional valve: Circuit interrupted Warning buzzer MTS Digital input signal for ANS-LOCK (locking of automatic neutral and standstill) Output from additional valve: Short circuit to ground Door status Digital input signal for AUX-CON (auxiliary consumer) Page 248 of 276

SPN 04623 04623 04624 04624 04624 04625 04625 04625 04626 04626 04626

Control unit/System EBS_5 ZBRO DIW5 EBS_5 ZBRO DIW5 EBS_5 ZBRO DIW5 EBS_5 ZBRO

04627

DIW5

04627 04627 04628 04628 04628

EBS_5 ZBRO DIW5 EBS_5 ZBRO

04629 04629

EBS_5 ZBRO

04630 04630 04630

DIW5 EBS_5 ZBRO

04631 04631 04631

DIW5 EBS_5 ZBRO

04632

DIW5

04632 04632

EBS_5 ZBRO

04633 04633 04633

DIW5 EBS_5 ZBRO

04634

DIW5

04634 04634

EBS_5 ZBRO

04635

DIW5

04635 04635

EBS_5 ZBRO

04636 04636

EBS_5 ZBRO

04637 04637

EBS_5 ZBRO

04638 04638

EBS_5 ZBRO

04639

EBS_5

SD 812a en-online 05.2007

Fault message Output from additional valve: Short circuit after terminal 30 Door 1 / panel 1 check Digital input signal for forced neutral (FRCD-NEUT) Output from additional valve: Short circuit in circuit Door 1 / panel 1 button Digital input signal for BSB-IN (bus stop brake input) Output from additional valve: Installed but not configured Door 1 / panel 1 button Digital input signal for FB-OFF (foot brake off) (!) Wheel sensor wheel 9 Door 1 / panel 2 check Digital input signal for GEAR_ENBL (gear guard enable input signal) Wheel sensor wheel 9: Connection cable damaged or sensor defective Door 1 / panel 2 button Digital input signal for LIMP_HOME (limp home input signal) (!) Wheel sensor wheel 10 Door 1 / panel 2 button Wheel sensor wheel 10: Connection cable damaged or sensor defective Door 1 check Gearbox mechanism, engine speed acquisition, gearbox output speed acquisition, turbine speed acquisition Brake pad wear connection wheel 9 Door 1 check Gearbox mechanism, gearbox output speed acquisition, engine speed acquisition, turbine speed acquisition Brake pad wear sensor signal wheel 9 Door 1 emergency tap actuated Gearbox mechanism, turbine speed acquisition, engine speed acquisition, gearbox output speed acquisition Brake pad wear sensor wheel 9: Difference between the 2 signals on the left and right sides of the axle too great Door 1 disrupted Engine speed acquisition (sensor voltage gearbox control unit) Brake pad wear sensor signal wheel 10 Door 1 button Gearbox output speed acquisition (sensor voltage gearbox control unit) Brake pad wear sensor wheel 10: Difference between the 2 signals on the left and right sides of the axle too great Door 1 button Turbine speed acquisition (sensor voltage gearbox control unit) Pressure module control unit on wheel 7, incompatible software components Door 2 check Pressure module control unit on wheel 7, fault in electronic circuit Door 2 check Pressure module control unit on wheel 7, internal control unit test incorrect Door 2 emergency tap actuated Pressure module control unit on wheel 7, unknown pressure control module fault code Door 2 disrupted Pressure module control unit on wheel 7, incorrect system monitoring after activation Page 249 of 276

SPN 04639

Control unit/System ZBRO

04640 04640

EBS_5 ZBRO

04641 04641

EBS_5 ZBRO

04642 04642

EBS_5 ZBRO

04643 04643

EBS_5 ZBRO

04644 04644

EBS_5 ZBRO

04645 04645

EBS_5 ZBRO

04646 04646

EBS_5 ZBRO

04647 04647

EBS_5 ZBRO

04648 04648

EBS_5 ZBRO

04649 04649 04650

EBS_5 ZBRO DIW5

04650 04650 04651

EBS_5 ZBRO DIW5

04651 04651 04652

EBS_5 ZBRO DIW5

04652 04652 04653

EBS_5 ZBRO DIW5

04653 04653 04654

EBS_5 ZBRO DIW5

04654 04654 04655

EBS_5 ZBRO DIW5

04655 04655

EBS_5 ZBRO

04656 04656

EBS_5 ZBRO

04657

EBS_5

SD 812a en-online 05.2007

Fault message Door 2 button Pressure module control unit on wheel 8, incompatible software components Door 2 button Pressure module control unit on wheel 8, fault in electronic circuit Door 3 check Pressure module control unit on wheel 8, internal control unit test incorrect Door 3 check Pressure module control unit on wheel 8, unknown pressure control module fault code Door 3 disrupted Pressure module control unit on wheel 8, incorrect system monitoring after activation Door 3 button Pressure module control unit on wheel 9, incompatible software components Door 3 button Pressure module control unit on wheel 9, fault in electronic circuit Door 4 check Pressure module control unit on wheel 9, internal control unit test incorrect Door 4 check Pressure module control unit on wheel 9, unknown pressure control module fault code Door 4 button Pressure module control unit on wheel 9, incorrect system monitoring after activation Door 4 button Digital output signal BRK-SIG (brake signal) Pressure module control unit on wheel 10, incompatible software components Block door panel 1 Digital output signal BSB-OUT (bus stop brake out) Pressure module control unit on wheel 10, fault in electronic circuit Block door panel 1 Digital output signal NEUT-SIG (neutral signal) Pressure module control unit on wheel 10, internal control unit test incorrect Block door panel 2 Digital output signal RG-SIG (reverse gear signal) Pressure module control unit on wheel 10, unknown pressure control module fault code Block door panel 2 Digital output signal SPD-SIG (speed signal) Pressure module control unit on wheel 10, incorrect system monitoring after activation Door release Digital output signal TEMP-SIG (temperature signal) Pressure module control unit on wheel 7, EEPROM data record is not compatible with the system Door release Pressure module control unit on wheel 7, EEPROM cannot be written Door release checkback MTS Pressure module control unit on wheel 8, EEPROM data record is not compatible with the system Page 250 of 276

SPN 04657 04658

Control unit/System ZBRO DIW5

04658 04658 04659

EBS_5 ZBRO DIW5

04659 04659

EBS_5 ZBRO

04660 04660

EBS_5 ZBRO

04661 04661

EBS_5 ZBRO

04662 04662

EBS_5 ZBRO

04663 04663 04664 04664

EBS_5 ZBRO EBS_5 ZBRO

04665 04665

EBS_5 ZBRO

04666 04666

EBS_5 ZBRO

04667 04667

EBS_5 ZBRO

04668 04668

EBS_5 ZBRO

04669 04669 04670 04670

EBS_5 ZBRO EBS_5 ZBRO

04671 04671

EBS_5 ZBRO

04672 04672 04673 04673

EBS_5 ZBRO EBS_5 ZBRO

04674 04674 04675 04675 04676 04676 04677 04677 04678 04678 04679

EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5

SD 812a en-online 05.2007

Fault message Ignition 1 on for MTS Digital output signal STRT-ENBL (starter enable) Pressure module control unit on wheel 8, EEPROM cannot be written Light enable Output signal PWN signal proportional to speed Pressure module control unit on wheel 9, EEPROM data record is not compatible with the system Request stop display Pressure module control unit on wheel 9, EEPROM cannot be written MTS activation (K3-CAN) Pressure module control unit on wheel 10, EEPROM data record is not compatible with the system Emergency tap Pressure module control unit on wheel 10, EEPROM cannot be written Door 1 external button Power supply pressure module on wheel 7, short circuit to terminal 15 Door 1 door release checkback Power supply pressure module on wheel 7 Door 2 door release checkback Power supply pressure module on wheel 7, short circuit between the connection cables Door 3 door release checkback Power supply pressure module on wheel 8, short circuit to terminal 15 Door 4 door release checkback Power supply pressure module on wheel 8, short circuit to terminal 15 Bus-stop switching backwards Power supply pressure module on wheel 8, short circuit between the connection cables Bus-stop switching backwards Power supply pressure module on wheel 9, short circuit to terminal 15 Bus-stop switching forwards Power supply pressure module on wheel 9 Bus-stop switching forwards Power supply pressure module on wheel 9, short circuit between the connection cables External request stop by person with disability Power supply pressure module on wheel 10, short circuit to terminal 15 Display request stop by person with disability Power supply pressure module on wheel 10 Door malfunction Power supply pressure module on wheel 10, short circuit between the connection cables Door 1 activation (K3-CAN) CAN signal brake on wheel 7 Door 1 / panel 1 open CAN signal brake on wheel 8 Door 1 / panel 1 opening CAN signal brake on wheel 9 Door 1 / panel 1 closing CAN signal brake on wheel 10 Door 1 / panel 2 open CAN signal brake on wheel 7, time overrun of message 11 Page 251 of 276

SPN 04679 04680 04680 04681 04681 04682 04682 04683 04683 04684 04684 04685 04685 04686 04686 04687 04687 04688 04688 04689 04689 04690 04690 04691 04691 04692 04692 04693 04693 04694 04694 04695 04695 04696 04696 04697 04697 04698 04698 04699 04699 04700 04700 04700 04701 04701 04701 04702 04702 04702

Control unit/System ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO DIW5 EBS_5 ZBRO DIW5 EBS_5 ZBRO DIW5 EBS_5 ZBRO

04703 04703 04703

DIW5 EBS_5 ZBRO

04704 04704 04704 04705 04705

DIW5 EBS_5 ZBRO DIW5 EBS_5

SD 812a en-online 05.2007

Fault message Door 1 / panel 2 opening CAN signal brake on wheel 7, time overrun of message 12 Door 1 / panel 2 closing CAN signal brake on wheel 7, time overrun of message 13 Door 1 request stop display CAN signal brake on wheel 7, time overrun of message 14 Door 1 request stop display CAN signal brake on wheel 7, time overrun of message 21 Door 1 request stop by person with disability CAN signal brake on wheel 7, time overrun of message 22 Door 1 ignition on CAN signal brake on wheel 7, time overrun of message 23 Door 1 entry lighting CAN signal brake on wheel 7, time overrun of message 24 Door 1 in local mode CAN signal brake on wheel 8, time overrun of message 11 Door 2 request stop by person with disability CAN signal brake on wheel 8, time overrun of message 12 Door 1 ready CAN signal brake on wheel 8, time overrun of message 13 Door 1 standstill signal CAN signal brake on wheel 8, time overrun of message 14 Door 2 activation (K3-CAN) CAN signal brake on wheel 8, time overrun of message 21 Door 2 / panel 1 open CAN signal brake on wheel 8, time overrun of message 22 Door 2 / panel 1 opening CAN signal brake on wheel 8, time overrun of message 23 Door 2 / panel 1 closing CAN signal brake on wheel 8, time overrun of message 24 Door 2 / panel 2 open CAN signal brake on wheel 9, time overrun of message 11 Door 2 panel 2 opening CAN signal brake on wheel 9, time overrun of message 12 Door 2 / panel 2 closing CAN signal brake on wheel 9, time overrun of message 13 Door 2 request stop display CAN signal brake on wheel 9, time overrun of message 14 Door 2 request stop display CAN signal brake on wheel 9, time overrun of message 21 Door 2 ignition on Unknown engine load source CAN signal brake on wheel 9, time overrun of message 22 Raise lift CAN message EEC2, CAN signal accelerator pedal position CAN signal brake on wheel 9, time overrun of message 23 Raise lift CAN message EEC1, CAN signal current engine torque CAN signal brake on wheel 9, time overrun of message 24 Lift in motion CAN message EngConf, CAN signal (percent torque at point 3,4,5) CAN signal brake on wheel 10, time overrun of message 11 Lower lift CAN message EEC3, CAN signal (nominal friction percent torque) CAN signal brake on wheel 10, time overrun of message 12 Lower lift CAN message EngConf, CAN signal engine reference torque CAN signal brake on wheel 10, time overrun of message 13 Page 252 of 276

SPN 04705

Control unit/System ZBRO

04706 04706 04706

DIW5 EBS_5 ZBRO

04707 04707 04707

DIW5 EBS_5 ZBRO

04708 04708 04708 04709 04709 04710 04710 04711

DIW5 EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO DIW5

04711 04711

EBS_5 ZBRO

04712 04712 04713 04713 04714 04714 04715 04715

EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO

04716 04716 04716 04717 04717 04717

DIW5 EBS_5 ZBRO DIW5 EBS_5 ZBRO

04718 04718 04718 04719 04719

DIW5 EBS_5 ZBRO EBS_5 ZBRO

04720

DIW5

04720 04720

EBS_5 ZBRO

04721

DIW5

04721 04721

EBS_5 ZBRO

04722 04722 04722

DIW5 EBS_5 ZBRO

04723

DIW5

SD 812a en-online 05.2007

Fault message Ramp full deployed CAN message EEC2, engine load signal (idling switch position) CAN signal brake on wheel 10, time overrun of message 14 Ramp in motion CAN message EEC1, engine load signal (nominal engine torque) CAN signal brake on wheel 10, time overrun of message 21 Ramp multifunction display Engine load source CAN: Error that cannot be diagnosed with greater precision. CAN signal brake on wheel 10, time overrun of message 22 Ramp enable CAN signal brake on wheel 10, time overrun of message 23 Ramp enable CAN signal brake on wheel 10, time overrun of message 24 Ramp flashing light Engine load source Bosch EDC Speed sensor input on pressure regulating module wheel 9, faulty electronic circuit Ramp fully retracted Speed sensor input on pressure regulating module wheel 10, faulty electronic circuit Door 2 entry lighting (!) Speed sensor wheel 9, air gap too great Door 2 in local mode (!) Speed sensor wheel 10, air gap too great Door 3 request stop by person with disability (!) Speed sensor wheel 9, impulse wheel defective Door 2 ready Engine load source Bosch EDC: Speed range in data record faulty. (!) Speed sensor wheel 10, impulse wheel defective Door 2 standstill signal Engine load source Bosch EDC: Error in engine map (!) Speed sensor wheel 9, tyre diameter too great Door 3 activation (K3-CAN) Engine load source Bosch EDC: Error that cannot be diagnosed with greater precision. (!) Speed sensor wheel 10, tyre diameter too great Door 3 / panel 1 open Pressure module intake valve on wheel 7 Door 3 / panel 1 opening Brake request evaluation: Unknown brake sensor in data record. Pressure module intake valve on wheel 7, valve cannot be switched and is opened Door 3 / panel 1 closing Brake request evaluation: Impermissible brake sensor combination in data record. Pressure module intake valve on wheel 7, valve cannot be switched and is closed Door 3 / panel 2 open Brake request evaluation: No brake sensor set in data record. Pressure module intake valve on wheel 8 Door 3 / panel 2 opening Brake request evaluation: Invalid brake sensor priority in data record. Page 253 of 276

SPN

Control unit/System

04723 04723

EBS_5 ZBRO

04724 04724 04724

DIW5 EBS_5 ZBRO

04725 04725

EBS_5 ZBRO

04726 04726 04727 04727

EBS_5 ZBRO EBS_5 ZBRO

04728 04728

EBS_5 ZBRO

04729 04729

EBS_5 ZBRO

04730 04730 04730 04731 04731 04731 04732 04732 04732 04733 04733 04733

DIW5 EBS_5 ZBRO DIW5 EBS_5 ZBRO DIW5 EBS_5 ZBRO DIW5 EBS_5 ZBRO

04734 04734 04734 04735 04735 04735

DIW5 EBS_5 ZBRO DIW5 EBS_5 ZBRO

04736 04736 04736

DIW5 EBS_5 ZBRO

04737 04737 04737

DIW5 EBS_5 ZBRO

04738 04738

EBS_5 ZBRO

04739 04739 04740 04740 04740 04741

EBS_5 ZBRO DIW5 EBS_5 ZBRO DIW5

SD 812a en-online 05.2007

Fault message Pressure module intake valve on wheel 8, valve cannot be switched and is opened Door 3 / panel 2 closing Brake request evaluation: Error that cannot be diagnosed with greater precision. Pressure module intake valve on wheel 9 Door 3 request stop display Pressure module intake valve on wheel 9, valve cannot be switched and is opened Door 3 request stop display Pressure module intake valve on wheel 9, valve cannot be switched and is closed Door 3 ignition on Pressure module intake valve on wheel 10 Door 3 entry lighting Pressure module intake valve on wheel 10, valve cannot be switched and is opened Door 3 in local mode Pressure module intake valve on wheel 10, valve cannot be switched and is closed Door 3 emergency tap actuated CAN message TSC1, CAN signal (override control mode priority) Brake pad wear connection wheel 2 Door 3 ready CAN message TSC1, CAN signal requested retarder limit Brake pad wear connection wheel 3 Door 3 standstill signal CAN message TSC1, CAN signal requested retarder torque Brake pad wear connection wheel 4 Door 4 activation (K3-CAN) CAN message EBC1, CAN signal brake pedal position Brake pad wear connection wheel 5 Door 4 / panel 1 open Set brake sensor source or CAN message TSC1, requested retarder torque Brake pad wear connection wheel 6 Door 4 / panel 1 opening CAN message TSC1, CAN signal: Requested torque / limit Brake pad wear connection wheel 7 Door 4 / panel 1 closing Brake signal source CAN: Brake pedal continuously pressed. Brake pad wear connection wheel 8 Door 4 / panel 2 open Brake signal source CAN: Error that cannot be diagnosed with greater precision. Pressure module exhaust valve on wheel 7 Door 4 / panel 2 opening Pressure module exhaust valve on wheel 7, valve cannot be switched and is opened Door 4 / panel 2 closing Pressure module exhaust valve on wheel 7, valve cannot be switched and is closed Door 4 request stop display Brake sensor signal source pedal brake sensor 3-stage Pressure module exhaust valve on wheel 8 Door 4 ignition on Brake sensor signal source infinitely variable (WABCO) Page 254 of 276

SPN

Control unit/System

04741 04741 04742

EBS_5 ZBRO DIW5

04742 04742 04743 04743

EBS_5 ZBRO EBS_5 ZBRO

04744 04744

EBS_5 ZBRO

04745 04745 04746 04746

EBS_5 ZBRO EBS_5 ZBRO

04747 04747

EBS_5 ZBRO

04748 04748 04749 04749

EBS_5 ZBRO EBS_5 ZBRO

04750 04750 04751 04751

EBS_5 ZBRO EBS_5 ZBRO

04752 04752 04753 04753

EBS_5 ZBRO EBS_5 ZBRO

04754 04754 04755 04755

EBS_5 ZBRO EBS_5 ZBRO

04756 04756 04757 04757 04758 04758 04759 04759 04760 04760 04761 04761 04762 04762 04763 04763 04764 04764 04765

EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5 ZBRO EBS_5

SD 812a en-online 05.2007

Fault message Pressure module exhaust valve on wheel 8, valve cannot be switched and is opened Door 4 entry lighting Brake sensor signal source parking brake sensor 3-stage Pressure module exhaust valve on wheel 8, valve cannot be switched and is closed Door 4 standstill signal Pressure module exhaust valve on wheel 9 Door 1 door release Pressure module exhaust valve on wheel 9, valve cannot be switched and is opened Door 2 door release Pressure module exhaust valve on wheel 9, valve cannot be switched and is closed Door 3 door release Pressure module exhaust valve on wheel 10 Door 4 door release Pressure module exhaust valve on wheel 10, valve cannot be switched and is opened Door 4 ready Pressure module exhaust valve on wheel 10, valve cannot be switched and is closed Door 4 in local mode Pressure module backup valve on wheel 7 Door 4 emergency tap actuated Pressure module backup valve on wheel 7, valve cannot be switched and is closed Door 4 request stop display Pressure module backup valve on wheel 8 Door 4 request stop by person with disability Pressure module backup valve on wheel 8, valve cannot be switched and is closed Door 2 interior sign/exterior sign Pressure module backup valve on wheel 9 Door 2 preliminary storage request stop Pressure module backup valve on wheel 9, valve cannot be switched and is closed Door 3 interior sign/exterior sign Pressure module backup valve on wheel 10 Door 3 preliminary storage request stop Pressure module backup valve on wheel 10, valve cannot be switched and is closed Enable 20:00 hours Pressure module pressure sensor on wheel 7, offset Enable 20:00 hours Pressure module pressure sensor on wheel 7, signal Enable 20:00 hours check Pressure module pressure sensor on wheel 8, offset Door 1 malfunction Pressure module pressure sensor on wheel 8, signal Door 1 warning Pressure module pressure sensor on wheel 9, offset Door 2 malfunction Pressure module pressure sensor on wheel 9, signal Door 2 warning Pressure module pressure sensor on wheel 10, offset Door 3 malfunction Pressure module pressure sensor on wheel 10, signal Door 3 warning Wheel 9: Brake performance monitoring Page 255 of 276

SPN 04765 04766 04766

Control unit/System ZBRO EBS_5 ZBRO

04767 04767

EBS_5 ZBRO

(!) Wheel 9 in conjunction with ABS logic: ABS is demanding insufficient brake pressure over an implausibly long time Door 1 auxiliary button

04768 04768 04769 04769

EBS_5 ZBRO EBS_5 ZBRO

(!) Wheel 10 in conjunction with ABS logic: ABS is demanding insufficient brake pressure over an implausibly long time Door 2 auxiliary button (!) Wheel 9 in conjunction with ABS logic: Wheel speed fault Waiting room

04770 04770

EBS_5 ZBRO

04771 04771

EBS_5 ZBRO

04772 04772

EBS_5 ZBRO

04773 04773

EBS_5 ZBRO

04774 04774

EBS_5 ZBRO

04775 04775

EBS_5 ZBRO

04776 04776

EBS_5 ZBRO

04777 04777

EBS_5 ZBRO

04778 04778

EBS_5 ZBRO

04779 04779

EBS_5 ZBRO

04780

DIW5

04780 04780 04781

EBS_5 ZBRO DIW5

04781 04781

EBS_5 ZBRO

04782

DIW5

SD 812a en-online 05.2007

Fault message Door 4 malfunction Wheel 10: Brake performance monitoring Door 4 warning

(!) Wheel 10 in conjunction with ABS logic: Wheel speed fault Waiting room (!) Wheel 9 in conjunction with ABS logic: Change between active and inactive ABS intervention too fast Door 1 preliminary storage request stop (!) Wheel 10 in conjunction with ABS logic: Change between active and inactive ABS intervention too fast Door 1 interior sign/exterior sign External sequential fault: Time overrun in communication with trailer control unit 3 Switch doors back to active External sequential fault: Time overrun in communication with trailer control unit 4 Switch doors back to active External sequential fault: Time overrun in communication with trailer control unit 5 Door manual/automatic (!) Pressure regulating module pressure control on wheel 7: Pressure comparison plausibility error: Request is greater than the measured pressure Request stop display 2 (!) Pressure regulating module pressure control on wheel 8: Pressure comparison plausibility error: Request is greater than the measured pressure Door 2 block (!) Pressure regulating module pressure control on wheel 9: Pressure comparison plausibility error: Request is greater than the measured pressure Door 1 constrained closing (!) Pressure regulating module pressure control on wheel 10: Pressure comparison plausibility error: Request is greater than the measured pressure Door 2 constrained closing Plug and cabling of the transmission identification module (TIM, identification data of the gearbox) (!) Pressure regulating module pressure control on wheel 7: Pressure comparison plausibility error: Measured pressure is greater than request Door 3 constrained closing Identification data of the gearbox (TIM) (!) Pressure regulating module pressure control on wheel 8: Pressure comparison plausibility error: Measured pressure is greater than request Cancel stop request button Incorrect response from transmission identification module (TIM) Page 256 of 276

SPN

Control unit/System

04782 04782

EBS_5 ZBRO

04783

DIW5

04783 04783 04784

EBS_5 ZBRO DIW5

04784 04784

EBS_5 ZBRO

04785

DIW5

04785 04785

EBS_5 ZBRO

04786 04786

EBS_5 ZBRO

04787 04787

EBS_5 ZBRO

04788 04788

EBS_5 ZBRO

04789 04789

EBS_5 ZBRO

04790 04790

EBS_5 ZBRO

04791 04791

EBS_5 ZBRO

04792 04792

EBS_5 ZBRO

04793 04793

EBS_5 ZBRO

04794 04794

EBS_5 ZBRO

04795 04795

EBS_5 ZBRO

04796 04796

EBS_5 ZBRO

04797 04797

EBS_5 ZBRO

SD 812a en-online 05.2007

Fault message (!) Pressure regulating module pressure control on wheel 9: Pressure comparison plausibility error: Measured pressure is greater than request Block door 3 20:00 hours Negative response from transmission identification module (TIM) (!) Pressure regulating module pressure control on wheel 10: Pressure comparison plausibility error: Measured pressure is greater than request Baby carriage door 3 New combination of gearbox and control unit (software) (!) Pressure regulating module pressure control on wheel 7: Full braking test Cancel baby carriage door 3 TIM communication was deactivated because of increased gear oil temperature (!) Pressure regulating module pressure control on wheel 8: Full braking test Ramp weight overload (!) Pressure regulating module pressure control on wheel 9: Full braking test Stop request chime (!) Pressure regulating module pressure control on wheel 10: Full braking test Switch off chime switch (!) Pressure regulating module pressure control on wheel 7: Mismatch between pressure control module pressure and supply pressure Emergency exit door (!) Pressure regulating module pressure control on wheel 8: Mismatch between pressure control module pressure and supply pressure Door 1 blocking (!) Pressure regulating module pressure control on wheel 9: Mismatch between pressure control module pressure and supply pressure Door 3 blocking (!) Pressure regulating module pressure control on wheel 10: Mismatch between pressure control module pressure and supply pressure Door 4 blocking (!) Pressure regulating module pressure control on wheel 7: Temporary backup test Door 4 forced closing (!) Pressure regulating module pressure control on wheel 8: Temporary backup test Door 4 interior transfer/external button (!) Pressure regulating module pressure control on wheel 9: Temporary backup test Door 4 preliminary storage request stop (!) Pressure regulating module pressure control on wheel 10: Temporary backup test Door 4 disrupted (!) Pressure regulating module pressure control on wheel 7: Temporary brake test Door 3 additional button (!) Pressure regulating module pressure control on wheel 8: Temporary brake test Door 4 additional button Page 257 of 276

SPN

Control unit/System

04798 04798

EBS_5 ZBRO

04799 04799 04800

EBS_5 ZBRO DIW5

04800 04800 04801

EBS_5 ZBR2 DIW5

04801 04801

EBS_5 ZBRO

04802

DIW5

04802 04802

EBS_5 ZBRO

04803 04803

EBS_5 ZBRO

04804 04804

EBS_5 ZBRO

04805 04805

EBS_5 ZBRO

04806 04806

EBS_5 ZBRO

04807 04807

EBS_5 ZBRO

04808 04808

EBS_5 ZBRO

04809 04809 04810

EBS_5 ZBRO DIW5

04810 04810

EBS_5 ZBRO

04811

DIW5

04811 04811

EBS_5 ZBRO

04812

DIW5

04812 04812

EBS_5 ZBRO

04813

DIW5

SD 812a en-online 05.2007

Fault message (!) Pressure regulating module pressure control on wheel 9: Temporary brake test Door 1 photoelectric barrier/sensor (!) Pressure regulating module pressure control on wheel 10: Temporary brake test Door 1 photoelectric barrier/sensor Kickdown input (!) Pressure regulating module pressure control on wheel 7: Implausible pressure differential right/left Status signal, central locking CAN message EEC2, CAN signal kick-down switch (!) Pressure regulating module pressure control on wheel 8: Implausible pressure differential right/left Central locking left checkback open CAN message EEC2, CAN signal kick-down switch or kick-down digital input (!) Pressure regulating module pressure control on wheel 9: Implausible pressure differential right/left Open central locking left (!) Pressure regulating module pressure control on wheel 10: Implausible pressure differential right/left Open central locking left (!) Pressure regulating module pressure control on wheel 7: Implausible pressure when no braked applied Lock central locking left (!) Pressure regulating module pressure control on wheel 8: Implausible pressure when no braked applied Lock central locking left (!) Pressure regulating module pressure control on wheel 9: Implausible pressure when no braked applied Central locking left checkback locked (!) Pressure regulating module pressure control on wheel 10: Implausible pressure when no braked applied Central locking right checkback open (!) Pressure regulating module pressure control on wheel 7: Implausible pressure at end of braking Open central locking right (!) Pressure regulating module pressure control on wheel 8: Implausible pressure at end of braking Open central locking right Evaluation gear selection range (!) Pressure regulating module pressure control on wheel 9: Implausible pressure at end of braking Lock central locking right CAN message TC1, CAN signal: Requested gear or requested drive range (!) Pressure regulating module pressure control on wheel 10: Implausible pressure at end of braking Lock central locking right Evaluation gear selection range: Gear information from button switch outside permitted value range or CAN signal requested gear or requested range outside the permitted value range. (!) Pressure regulating module pressure control on wheel 7: Implausible intake valve actuation Central locking right checkback locked Evaluation gear selection range: Gear information from button switch incorrect or CAN signals requested gear or requested range return an error identification. Page 258 of 276

SPN

Control unit/System

04813 04813

EBS_5 ZBRO

04814

DIW5

04814 04814

EBS_5 ZBRO

04815

DIW5

04815 04815

EBS_5 ZBRO

04816 04816

EBS_5 ZBRO

04817

EBS_5

04818

EBS_5

04819 04820

EBS_5 DIW5

04820 04821

EBS_5 DIW5

04821 04822

EBS_5 DIW5

04822

EBS_5

04823

EBS_5

04824 04825

EBS_5 DIW5

04825

EBS_5

04826

EBS_5

04827

EBS_5

04828

EBS_5

04829 04830

EBS_5 DIW5

04830 04831

EBS_5 DIW5

04831 04832

EBS_5 DIW5

04832

EBS_5

04833

DIW5

04833

EBS_5

SD 812a en-online 05.2007

Fault message (!) Pressure regulating module pressure control on wheel 8: Implausible intake valve actuation Central locking flaps left Evaluation gear selection range: Error in plausibility check within the gearbox control unit or CAN signals requested gear and requested range are contradictory. (!) Pressure regulating module pressure control on wheel 9: Implausible intake valve actuation Central locking flaps right Evaluation gear selection range: Error that cannot be diagnosed with greater precision. (!) Pressure regulating module pressure control on wheel 10: Implausible intake valve actuation CL flaps left fault (!) Pressure regulating module pressure control on wheel 7: Implausible exhaust valve actuation CL flaps right fault (!) Pressure regulating module pressure control on wheel 8: Implausible exhaust valve actuation (!) Pressure regulating module pressure control on wheel 9: Implausible exhaust valve actuation (!) Pressure regulating module pressure control on wheel 10: Implausible exhaust valve actuation CAN messages CCVS and EBC1, CAN signal brake switch (!) Pressure regulating module pressure control on wheel 7: Residual pressure detected CAN message CCVS, vehicle speed signal (wheel speed) (!) Pressure regulating module pressure control on wheel 8: Residual pressure detected CAN message LFC, fuel consumption signal (!) Pressure regulating module pressure control on wheel 9: Residual pressure detected (!) Pressure regulating module pressure control on wheel 10: Residual pressure detected Pressure module control unit on wheel 7, checksum error in external flash memory Supply voltage Pressure module control unit on wheel 7, outdated driver software Pressure module control unit on wheel 8, inconsistent driver software version between ECU and boot loader Pressure module control unit on wheel 8, checksum error in external flash memory Pressure module control unit on wheel 8, outdated driver software Pressure module control unit on wheel 9, inconsistent driver software version between ECU and boot loader Reference voltage Pressure module control unit on wheel 9, checksum error in external flash memory Reference voltage: Undervoltage Uref. Pressure module control unit on wheel 9, outdated driver software Reference voltage: Overvoltage Uref. Pressure module control unit on wheel 10, inconsistent driver software version between ECU and boot loader Reference voltage: Error that cannot be diagnosed with greater precision. Pressure module control unit on wheel 10, checksum error in external flash memory Page 259 of 276

SPN

Control unit/System

04834

EBS_5

04835

EBS_5

04836

EBS_5

04837

EBS_5

04838

EBS_5

04839 04840

EBS_5 DIW5

04840

EBS_5

04841

EBS_5

04842

EBS_5

04843

EBS_5

04844

EBS_5

04845

EBS_5

04846

EBS_5

04847

EBS_5

04848

EBS_5

04849

EBS_5

04850 04850

DIW5 EBS_5

04851

DIW5

04851

EBS_5

04852

DIW5

04852

EBS_5

04853

DIW5

04853

EBS_5

04854 04854

DIW5 EBS_5

04855 04855

DIW5 EBS_5

SD 812a en-online 05.2007

Fault message Pressure module control unit on wheel 10, outdated driver software Supply voltage brake pad wear sensor wheel 9: Short circuit to ground Supply voltage brake pad wear sensor wheel 10: Short circuit to ground Supply voltage brake pad wear sensor wheel 9: was deactivated Supply voltage brake pad wear sensor wheel 10: was deactivated Pressure module supply cable to wheel 7: Current magnitude too high Engine control unit, gearbox control unit Pressure module supply cable to wheel 8: Current magnitude too high Pressure module supply cable to wheel 9: Current magnitude too high Pressure module supply cable to wheel 10: Current magnitude too high Brake pad wear sensor wheel 9: Monitoring of brake pad wear signal (decreasing) between the axles of the vehicle Brake pad wear sensor wheel 10: Monitoring of brake pad wear signal (decreasing) between the axles of the vehicle Brake pad wear sensor wheel 9: Monitoring of brake pad wear signal (decreasing) within the axles Brake pad wear sensor wheel 10: Monitoring of brake pad wear signal (decreasing) within the axles Pressure module control unit on wheel 9: Axle load sensor electrical power supply is not switched on Pressure module control unit on wheel 9: Axle load sensor electrical power supply short circuit to terminal 30 Pressure module control unit on wheel 9: incorrect / inconsistent data record parameter in EEPROM Software module event memory: Data record value EVENTMEM_DELETE_ELEMENT_AFTER_ is set to '0' which is not permitted. CAN signal brake on wheel 9: No communication Software module event memory: An error was detected in the software when checking the EventTab event table. Pressure module control unit on wheel 10: Axle load sensor electrical power supply is not switched on Software module event memory: A signalled event is in the EventTab event table without reference. Pressure module control unit on wheel 10: Axle load sensor electrical power supply short circuit to terminal 30 Software module event memory: There is no reference in the form of a DTC column in the EventTab event table as the basis for the OEM_ID_ data record value. The non-referenced data record value is specified in the system description. Pressure module control unit on wheel 10: incorrect / inconsistent data record parameter in EEPROM Software module event memory: A defect was detected in the event memory structure. The structure has been set up again. This means any stored events have been lost. CAN signal brake on wheel 10: No communication Software module event memory: A diagnostic object is signalling multiple instances of one error type. Pressure regulating valve left: implausible activation time Page 260 of 276

SPN

Control unit/System

04856

DIW5

04856

EBS_5

04857 04857

DIW5 EBS_5

04858

EBS_5

04859 04860

EBS_5 DIW5

04860

EBS_5

04861

DIW5

04861 04862

EBS_5 DIW5

04862

EBS_5

04863 04863

DIW5 EBS_5

04864

DIW5

04864

EBS_5

04865

DIW5

04865

EBS_5

04866

DIW5

04866

EBS_5

04867

EBS_5

04868

EBS_5

04869 04870

EBS_5 DIW5

04870 04871

EBS_5 DIW5

04871 04872

EBS_5 DIW5

04872 04873

EBS_5 DIW5

04873 04874 04874

EBS_5 DIW5 EBS_5

SD 812a en-online 05.2007

Fault message Software module event memory: The size of a system description of a diagnostic object is greater than the available memory space. Pressure regulating valve left intake valve: Short circuit between the connections Software module event memory: Buffer overrun of the (reentrantcapable) event memory or calls of the (non-reentrant-capable) event memory outside the time slices. Pressure regulating valve right: implausible activation time Pressure regulating valve right intake valve: Short circuit between the connections Pressure regulating valve left exhaust valve: Short circuit between the connections Gearshift manager: Invalid gearshift program in data record. Pressure regulating valve right exhaust valve: Short circuit between the connections Gearshift manager: Invalid dynamic tyre radius in data record. Pressure module exhaust valve on wheel 6, valve cannot be switched and is closed Gearshift manager: Invalid axle ratio in data record. J1939 (driveline CAN): Time overrun or fault condition in communication with engine control unit (SA=0x00) Gearshift manager: Invalid maximum gear hunting time in data record. Brake pad wear connection wheel 10 Gearshift manager: Invalid maximum time for a forced downshift in data record. Pressure module intake valve on wheel 8, valve cannot be switched and is closed Gearshift manager: Incorrectly configured gearshift program in data record. Central control unit EEPROM: Implausible values in 'General ABS configuration' block Gearshift manager: Error that cannot be diagnosed with greater precision. Central control unit EEPROM: Checksum error in 'General ABS configuration' block External sequential fault: Time overrun or fault condition in communication with engine control unit (SA=0x00) External sequential fault: Time overrun or fault condition in communication with vehicle management computer control unit (SA=0x27) External sequential fault: Time overrun or fault condition in communication with tachograph (SA=0xEE) Security Manager software module External sequential fault: Time overrun or fault condition in communication with TCU control unit (SA=0x03) Identification data software module External sequential fault: Time overrun or fault condition in communication with EAC control unit (SA=0x30) Safety computer External sequential fault: Time overrun or fault condition in communication with ECAS control unit (SA=0x2F) Memory test External sequential fault: Time overrun or fault condition in communication with central on-board computer control unit (SA=0x21) Internal system error (TRAP error) Steering angle sensor not calibrated Page 261 of 276

SPN

Control unit/System

04875

DIW5

04875 04877

EBS_5 DIW5

04879 04880

DIW5 DIW5

04900 04900 04901 04901 04902 04902 04903 04903 04904 04904 04905 04905

DIW5 ZBRO DIW5 ZBRO DIW5 ZBRO DIW5 ZBRO DIW5 ZBRO DIW5 ZBRO

04909

DIW5

04910

DIW5

04911 04912

DIW5 DIW5

04913

DIW5

04914 04915

DIW5 DIW5

04919 04920 04921 04922 04923 04924 04925 04926 04927 04928 04929 04930

DIW5 DIW5 DIW5 DIW5 DIW5 DIW5 DIW5 DIW5 DIW5 DIW5 DIW5 DIW5

04931 04932

DIW5 DIW5

04933

DIW5

04934

DIW5

04935 04936 04937 04938 04939

DIW5 DIW5 DIW5 DIW5 DIW5

SD 812a en-online 05.2007

Fault message Analog/digital converter: ADC still occupied or ADC channel faulty. CAN bus fault: Time overrun or fault condition in communication with the electronically steered rear axle CAN message time / date Calibration data (for correcting hardware/component tolerances) Gearbox mechanical system: Blocking of output detected. CAN 1 - hardware: Memory test of CAN controller 1 was unsuccessful or defect within CAN controller 1 (RAM test). Sun blind auto Bus-off CAN2 Sun blind down high CAN warning CAN2 Sun blind down low Timeout monitoring send messages CAN2 Sun blind up Send buffer overrun CAN2 Sun blind up high CAN 1 - hardware: Invalid bitrate. Sun blind up low CAN 1 - hardware: Error that cannot be diagnosed with greater precision. CAN 2 - hardware: Memory test of CAN controller 2 was unsuccessful or defect within CAN controller 2 (RAM test). CAN 2 - hardware: Occurrence of BUS-OFF states. Failures of CAN bus by occurrence of BUS-OFF states. CAN 2 - hardware: Occurrence of BUS warning states. CAN 2 - hardware: At least one message could not be sent within timeout time of send messages. CAN 2 - hardware: Send buffer overrun or pipeline sending messages of CAN controller 2 is full. CAN 2 - hardware: Invalid bitrate. CAN 2 - hardware: Error that cannot be diagnosed with greater precision. CAN receipt message EEC1, timeout of the message CAN receipt message EEC2, timeout of the message CAN receipt message EEC3, timeout of the message CAN receipt message EBC1, timeout of the message CAN receipt message EBC3, timeout of the message CAN receipt message TSC1, timeout of the message CAN receipt message TSC1, timeout of the message CAN receipt message CCVS, timeout of the message CAN receipt message TC1, timeout of the message CAN receipt message TD, timeout of the message CAN receipt message VDHR, timeout of the message CAN protocol SAE J1939: Invalid CAN controller number in data record. CAN receipt message, timeout of the message CAN receipt message, timeout between the packages of the message CAN receipt message, number of bytes in the receipt message CAN receipt message, package sequence in the receipt message CAN receipt message TSC1, timeout of the message CAN receipt message LFC, timeout of the message CAN receipt message EBC5, timeout of the message CAN receipt message EBC5, timeout of the message Page 262 of 276

SPN

Control unit/System

04949

DIW5

04950

DIW5

04951

DIW5

04960

DIW5

04961

DIW5

04962

DIW5

04963

DIW5

04964

DIW5

04965

DIW5

04969 05000 05000 05000 05000 05000 05001 05001 05001 05001 05001 05001 05001

DIW5 ECO2 HDS VSM ZBR2 ZFR CRT ECO2 HDS RAS VSM WSK ZBR2

05001 05002 05002 05002 05002 05002 05002 05002 05003 05003 05003 05003 05003 05003 05004 05004 05004 05004 05004 05004 05005 05005 05005 05005 05005 05005 05005

ZFR CRT HDS RAS VSM WSK ZBRO ZFR CRT HDS RAS VSM ZBRO ZFR CRT HDS RAS WSK ZBRO ZFR CRT HDS RAS VSM WSK ZBRO ZFR

SD 812a en-online 05.2007

Fault message CAN protocol SAE J1939: Error that cannot be diagnosed with greater precision. Earth cable of the solenoid valves. Gearbox control unit, solenoid valve earth cable cannot be closed. Earth cable of the solenoid valves. Gearbox control unit, solenoid valve earth cable cannot be separated. The control unit plugs A, B on the E300.1 gearbox control unit and/or the gearbox plug are disconnected CAN protocol VOITH private CAN: Timeout of message INPUT VALUES 0. CAN protocol VOITH private CAN: Timeout of message INPUT VALUES 1. CAN protocol VOITH private CAN: Timeout of message INPUT VALUES 2. CAN protocol VOITH private CAN: Timeout of message CMD_Response. The operational data structure has been set up again/modified CAN protocol VOITH private CAN: Error that cannot be diagnosed with greater precision. ZF environmental condition Air pressure sensor after throttle Time overrun message ETC1 Audio-visual warning device and display CAN data bus: EDC message EEC1 CAN message engine temperature ZF environmental condition Air pressure ahead of throttle Oil level check Time overrun message ETC2 Retarder accumulator charge valve Check, instrumentation failure CAN data bus: Torque converter and clutch system message Transmission Fluid WSK CAN message EEC1 Temperature after catalytic converter Steering angle sensor front axle Time overrun message ETC3 Valve of torque converter lockup clutch Alarm level red (prio. 1) check CAN data bus: EDC message Eng Temp CAN message BAM Temperature ahead of catalytic converter Steering angle sensor steered rear axle Time overrun message EBC1 Switch off display lighting CAN data bus: EDC message Inlet Exhaust Condition CAN messages AdBlue pressure Speedometer / EBC speed signal comparison Retarder proportional valve Display dimming (0-15) CAN data bus: Tachograph message TCO1 Exhaust temperature sensor AdBlue temperature in pump module Shut-off valve Time overrun message EEC1 Retarder proportional valve, fault Display dimming bottom pressed CAN data bus: Retarder message ERC1_RE Page 263 of 276

SPN 05006 05006 05006 05006 05006 05006 05007 05007 05007 05007 05007 05008 05008 05008 05008 05008 05008 05009

Control unit/System CRT HDS RAS WSK ZBRO ZFR CRT HDS RAS ZBRO ZFR CRT HDS RAS WSK ZBRO ZFR CRT

05009 05009 05009 05009 05009 05010 05010 05010 05010 05010 05011 05011 05011 05011 05011 05012 05012 05012 05012 05012 05012 05012 05012 05013 05013 05013 05013 05013 05013 05013 05014 05014 05014 05014 05014 05014 05015 05015 05015 05015 05015

HDS RAS WSK ZBRO ZFR CRT HDS WSK ZBRO ZFR CRT HDS WSK ZBRO ZFR CRT ECO2 HDS RAS VSM WSK ZBRO ZFR CRT ECO2 HDS RAS VSM ZBRO ZFR CRT ECO2 HDS RAS ZBRO ZFR CRT ECO2 HDS RAS WSK

SD 812a en-online 05.2007

Fault message Exhaust differential pressure sensor EEPROM error Control valve working circuit Output earth return proportional valve Display dimming top pressed CAN data bus: Retarder message ERC1_RX Charge air temperature sensor Frost monitoring Deviation from setpoint in steering angle of rear axle Display change 1 CAN data bus: Retarder message ERC1_RD Engine brake butterfly Emergency off switch-off Monitoring circuit control unit Turbine speed: No signal Display change 2 CAN data bus: Retarder message Ret_Config_BAM (RE) CRT temperature too low for regeneration External hose heating (frozen line detected between tank and pump module) Working circuit control unit for valve control Sensor, cooling water temperature Horn CAN data bus: Retarder message Ret_Config_Packet (RE) CRT is not regenerating although filter temperature is correct Nitrogen oxide (NOx) sensor Read-back current of the proportional valve output Horn CAN data bus: Retarder message Ret_Config_BAM (RX) CRT is blocked and must be cleaned Metering on/off via CAN Vehicle electrical system voltage (TL 30) Horn a CAN data bus: Retarder message Ret_Config_Packet (RX) CRT temperature too high Load sensor (A3) Air control valve CAN signal, speedometer speed Time overrun message Time_Date Vehicle electrical system voltage (TL 15) Horn b CAN data bus: Retarder message Ret_Config_BAM (RD) Charge air temperature outside permitted tolerance range Voltage output (5V) AU Heating supply line CAN signal, EBC vehicle speed Time overrun message VehicleDistance Supply instrument lighting CAN data bus: Retarder message Ret_Config_Packet (RD) CAN message EEC3 Retarder control lever (A12) Hose heating internal CAN signal, engine speed Display day/night changeover CAN data bus: Tachograph message TimeDate CAN message time / date Voltage failure Heating pressure equalisation CAN signal, weight Checksum operating hours counter Page 264 of 276

SPN 05015 05015 05016 05016 05016 05016 05016 05016 05017 05017 05017 05017 05017 05017 05018 05018 05018 05018 05018 05018 05018 05019 05019 05019 05019 05019 05020 05020 05020 05020 05020 05020 05021 05021 05021 05021 05021 05022 05022 05022 05022 05022 05023 05023 05023 05024 05024 05024 05024 05025 05025 05025 05025 05025 05026 05026 05026 05027

Control unit/System ZBRO ZFR CRT ECO2 HDS RAS WSK ZBRO CRT ECO2 HDS RAS WSK ZBRO CRT ECO2 HDS RAS VSM WSK ZBRO CRT HDS RAS WSK ZBRO CRT HDS RAS VSM WSK ZBRO CRT ECO2 HDS WSK ZBRO CRT ECO2 HDS WSK ZBRO ECO2 HDS ZBRO ECO2 HDS WSK ZBRO ECO2 HDS RAS WSK ZBRO ECO2 HDS RAS ECO2

05027

HDS

SD 812a en-online 05.2007

Fault message Buzzer alarm level CAN data bus: Tachograph message Vehicle Distance CAN message vehicle clearance Switch retarder (retarder pedal digital S12) Pump heating in pump module CAN signal, lifting axle Checksum fault memory Buzzer function indicator AGR throttle Retarder temperature sensor (B4) Heating pressure line CAN signal, parking brake Data bus, message EEC2 from FFR Buzzer advance warning level Internal system fault Sump temperature sensor (B14) AdBlue metering module CAN signal, bus transmitter-receiver EEPROM error Engine brake Adv. warning level yellow (prio. 2) check EEPROM memory defective Coolant valve for AdBlue heating circuit Calibrate parameter value Internal system error control unit On-board diagnosis fault Exhaust temperature after the filter AdBlue fill level plausibility error ZF environmental condition EEPROM error Data bus, message TSC1 (braking torque) On-board diagnosis enable CAN message ETC 1 Output to gear element A valve (Y17) Detection of overspeeding and pump motor blocked CAN data bus, memory overflow Horn changeover CRT filter burnt out or not fitted Output to gear element B valve (Y16) Bleed valve output stage CAN data bus, switched off Horn changeover Output to gear element C valve (Y15) Blocked nozzle Horn changeover check Output to gear element D valve (Y14) Air pressure sensor plausibility CAN data bus, receive confirmation Outside temperature Output to gear element E valve (Y13) Air control valve fault during startup Calibration Data bus, message EEC1 from FFR Ice warning Output to gear element F valve (Y12) Blockage of air control valve Ambient temperature Output to gear element G valve (Y11) Air control valve mechanically open or closed, or no compressed air in circuit 4 Page 265 of 276

SPN 05027 05027 05027 05028 05028 05028 05029 05029 05029 05030 05030 05031 05031 05032 05032 05033 05033 05034 05034 05035 05035 05036 05036 05037 05037 05038 05038 05039 05039 05041 05042 05043 05043 05044 05045 05046 05047 05048 05049 05051 05051 05052 05053 05054 05055 05056 05057 05058 05059 05062 05063 05064 05065 05066 05067 05068 05071 05072 05073 05074

Control unit/System RAS VSM WSK ECO2 HDS WSK ECO2 HDS WSK HDS WSK ECO2 HDS ECO2 HDS ECO2 HDS ECO2 HDS ECO2 HDS ECO2 HDS ECO2 HDS ECO2 HDS ECO2 HDS ECO2 ECO2 ECO2 VSM ECO2 ECO2 ECO2 ECO2 ECO2 ECO2 ECO2 HDS ECO2 ECO2 ECO2 ECO2 ECO2 ECO2 ECO2 ECO2 ECO2 ECO2 ECO2 ECO2 ECO2 ECO2 ECO2 ECO2 ECO2 ECO2 ECO2

SD 812a en-online 05.2007

Fault message Rear axle too close to measured stop Time overrun message TCO1 Data bus, message ETC1_TCU Output to torque converter lock-up clutch WK valve (Y18) Temperature after catalytic converter Data bus, message TC1_TWSK from ASTRONIC Output to retarder accumulator valve (Y2) Detection of blocked metering module Time / date message from TCO Pump motor fault during startup Data bus, mileage (km) message Output to engine brake relay (K1) Unable to build up AdBlue pressure Output to gear signal relay (K2) Temperatures not plausible during startup Output to gear signal relay 2 AdBlue pressure not plausible Output to speed signal relay (K3) AdBlue temperature of pump module Output to speed signal relay 2 AdBlue temperature of tank Output to power take-off valve (Y3) Bleed valve implausible during startup Output to accelerator interlock valve (Y4) Bleed valve implausible or return line blocked during startup Output to load enable relay (K11) Temperature fault ahead of catalytic converter Output to detent solenoid relay (K4) Temperature fault after catalytic converter Output to selector lever lamp Output ADVP (continuous signal) Output to retarder brake lamp relay (K10) Time overrun message EBC2 Output to proportional solenoid D1 (Y20) Output to retarder proportional solenoid (Y1) Selector lever (A2) Speedo signal output via pin SD2 (A10) PWM interface (A8) EEPROM data checksum CAN B application CAN AdBlue quality sensor System fault electronic control unit EST146 Malfunction SAE J 1708 (BUSOFF) Malfunction SAE J 1708 (warning) CAN A vehicle CAN Output to retarder on valve (Y19) Input speed (B13) Output speed (B11) Gearbox input speed (B12) Retarder identifier (B16) Gearbox coding Gearbox slip monitoring Retarder outlet temperature Sump temperature Digital output (AD) not occupied Control unit reset Temperature warning output PWM signal oil level sensor (B15) Temperature warning output Temperature warning output Page 266 of 276

SPN 05075 05076 05077 05078 05079 05080 05081

Control unit/System ECO2 ECO2 ECO2 ECO2 ECO2 HDS ECO2

05081 05082 05082 05083 05083 05084 05084 05085

HDS ECO2 HDS ECO2 HDS ECO2 HDS ECO2

05085 05086 05086 05087

HDS ECO2 HDS ECO2

05087

HDS

05088

HDS

05089

HDS

05090 05091

HDS ECO2

05091 05093 05094 05095 05096 05098 05100 05100 05100 05101 05101 05102 05102 05103 05103 05104 05104 05105 05106 05107 05108 05109 05110 05110 05111 05111 05112 05112 05113

HDS ECO2 ECO2 ECO2 ECO2 ECO2 HDS ZBRO ZFR ZBRO ZFR ZBRO ZFR ZBRO ZFR ZBRO ZFR ZBRO ZBRO ZBRO ZBRO ZBRO HDS ZBRO HDS ZBRO HDS ZBRO HDS

SD 812a en-online 05.2007

Fault message Retarder sensor 'Manual' (retarder control lever digital S12) Gear element slip time Motor limit WK slip monitoring Operating voltage Limit value error for exhaust mass and nitrogen oxide Output relay selector lever 'Neutral 1' Pressure differential between AdBlue pressure and ambient pressure Output relay selector lever 'Neutral 2' Temperature sensor pump module plausibility Output relay reversing light Temperature plausibility ahead of catalytic converter EEPROM data customer (checksum) Temperature plausibility after catalytic converter Output to status monitoring (H1) Coolant valve for AdBlue heating circuit is stuck in open position Output 'Neutral at standstill (NBS) active' AdBlue tank temperature plausibility Input terminal 15 Detection of increasing AdBlue leakage between pump module and metering module Detection of steady AdBlue leakage between pump module and metering module Plausibility error in running-on through AdBlue pressure sensor (AdBlue pressure too high after blowing out) Plausibility error in running-on through air pressure (air pressure differential ahead of/after the throttle too great) Special function 1 set in parameters Plausibility error in running-on through vent valve (insufficient pressure dissipation possible through vent valve) D1 shift pressure adaptation upshift under load D1 shift pressure adaptation coasting downshift Shift time adaptation Contact pressure adaptation Special function 2 set in parameters Dummy Radio Additional fan Radio Main fan Radio check Additional compressor Loudspeaker changeover external Speed-dependent output Loudspeaker changeover external Additional fan valve Loudspeaker changeover ext. check PA system PA system PA system check Input alarm system active AdBlue pressure Alarm system horn Compressed air ahead of throttle IBIS BON active Engine revs Switch on IBIS Metering volume Page 267 of 276

SPN 05113 05114 05114 05115 05116 05117 05118 05119 05120 05120 05121 05122 05126 05127 05128 05129 05130 05131 05200 05201 05202 05203 05204 05205 05206 05207 05208 05209 05210 05211 05212 05213 05215 05216 05217 05218 05219 05300 05301 05302 05303 05304 05305 05306 05307 05308 05309 05310 05311 05312 05313 05314 05315 05316 05317 05318 05319 05320 05321 05322

Control unit/System ZBRO HDS ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO HDS ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO

SD 812a en-online 05.2007

Fault message IBIS transmit active Status IBIS external loudspeaker IBIS mike active IBIS control input 1 (output) IBIS control input 2 (output) IBIS call IBIS call active Monitoring error in monitoring module IBIS acknowledgement IBIS acknowledgement active IBIS door criterion Switch canceller OFF Output canceller OFF Switch IBIS OFF Output IBIS OFF Switch coin box OFF Output coin box OFF Driver's area door Driver's area door Driver's area door check Driver's area door buzzer Destination box lighting Destination box lighting Destination box lighting Check Paying console/driver's area lighting Paying console/driver's area lighting Paying console/driver's area lighting check Paying console socket Paying console socket Paying console socket check Paying console lighting 1 Driver's area lighting Driver's area lighting 1 Driver's area lighting Paying console activation coin box Paying console activation coin box Economy circuit front-end heater Front-end heater circulating pump Front-end heater inclined seat valve Roof ventilator Roof ventilator left Roof ventilator right Roof duct heating Roof duct ventilation Roof hatch check Roof hatch 1 rear open Roof hatch 1 rear open Roof hatch 1 completely open Roof hatch 1 front open Roof hatch 1 front open Roof hatch 2 rear open Roof hatch 2 rear open Roof hatch 2 completely open Roof hatch 2 front open Roof hatch 2 front open Heating Air-conditioning requested Cool driver's area Coolant valve driver's area Page 268 of 276

SPN 05323 05324 05325 05326 05327 05328 05329 05330 05331 05332 05333 05334 05335 05336 05337 05338 05339 05340 05341 05342 05343 05344 05345 05346 05347 05348 05349 05350 05351 05352 05353 05354 05355 05356 05357 05358 05359 05360 05361 05362 05363 05364 05365 05366 05367 05368 05369 05370 05371 05372 05373 05374 05375 05376 05377 05378 05379 05380 05381 05382

Control unit/System ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO

SD 812a en-online 05.2007

Fault message Set driver's area to recirculating air Recirculation ventilation hatch front-end Roof duct blower reduction Ice warning air-conditioning Air-conditioning fault Set roof to fresh air Ventilation hatch roof + Compressor activated Input check air-conditioning Air conditioning idling speed increase Engine running to air-conditioning Terminal 58 to air-conditioning Air-conditioning circulating pump on Inclined seat valve from air-conditioning Auxiliary heater to air-conditioning Ventilation Passenger area heater stage 1 Heater fan 1 left stage 1 Heater fan 2 left stage 1 Heater fan 3 left stage 1 Heater fan 2a right stage 1 Heater fan 2b right stage 1 Passenger area heater stage 2 Heater fan 1 left stage 2 Heater fan 2 left stage 2 Heater fan 3 left stage 2 Heater fan 2a right stage 2 Heater fan 2b right stage 2 Heater fan 2c right stage 2 Interior thermostat (low=heating) Circulating pump a cooling water Circulating pump b cooling water Inclined seat valve cooling water Valve convector heating Auxiliary heater check Auxiliary heater economy circuit Auxiliary heater pre-set timer Auxiliary heater pre-set timer Auxiliary heater water v./circ. pump Roof ventilator Roof ventilator Roof ventilator Roof ventilator a Roof ventilator b Ventilation hatch roof Set roof to recirculating air Recirculation ventilation hatch roof + Recirculation ventilation hatch roof Interior thermostat fault Air-conditioning auxiliary heater request Passenger area heater stage 1 Passenger area heater stage 2 Interior thermostat (low=heating) Interior thermostat (high=heating) Roof ventilator fault Auxiliary heater fault Air-conditioning fault Driver's fan switched off or fault Driver's fan fault Pedestal heater stage 1 Page 269 of 276

SPN 05383 05384 05385 05386 05387 05388 05389 05390 05391 05392 05393 05394 05395 05396 05397 05398 05399 05400 05401 05402 05403 05404 05500 05500 05501 05501 05502 05502 05503 05503 05504 05504 05505 05505 05506 05506 05507 05507 05508 05508 05509 05509 05510 05510 05511 05511 05512 05513 05514 05515 05516 05600 05600 05700 05800 05801 05802 05803 05804 05805

Control unit/System ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO HDS ZBRO HDS ZBRO HDS ZBRO HDS ZBRO HDS ZBRO HDS ZBRO HDS ZBRO HDS ZBRO HDS ZBRO HDS ZBRO HDS ZBRO HDS ZBRO HDS HDS HDS HDS HDS KSM ZBR2 ZBR2 ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO

SD 812a en-online 05.2007

Fault message Pedestal heater stage 2 Pedestal heater stage 1 Pedestal heater stage 2 Sw. driver's fan 2nd stage switched off or defective Driver's fan stage 1 Driver's fan stage 2 Roof hatch 3 rear open Roof hatch 3 rear open Roof hatch 3 completely open Roof hatch 3 front open Roof hatch 3 front open Water pump requested Parking lights heating control Auxiliary heater requested via passenger area heater Recirculation/ventilation hatch Recirculation/ventilation hatch Interior thermostat forebody fault Driver's seat heating switch Driver's seat heating ATC fault Air-conditioning system lower deck Air-conditioning system upper deck CAN error (no AAI message) Window heater CAN error (no ABC message) Window heater CAN error (no ATI message) Mirror heaters CAN error (no EEC1 message) Mirror heater left CAN error (no ETP message) Mirror heater right CAN error (no CEXH message) Door window heater CAN error (no FEC message) Door window heater a CAN error (no IEC message) Door window heater b CAN error (no NO1 message) Door window heater c CAN error (no PRO message) Door window heater d CAN error (no CTDA message) Windscreen heater Control unit or 'Heating on' faulty Windscreen heater CAN error (no CVDR message) CAN error (no CUQS message) Catalytic converter has been thermally overloaded AdBlue fill level is in 'reserve area' Exhaust gas mass outside the limits Cab lock. Cab lock ACC rated distance Check CSR2 Check CSR2 Check CSR3 Check CSR3 Check CSR4 Check CSR4 Page 270 of 276

SPN 05806 05807 05808 05809 05810 05811 05812 05813 05814 05815 05816 05817 05818 05819 05820 05821 05822 05823 05824 05825 05826 05827 05828 05829 05830 05831 05832 05833 05834 05835 05836 05837 05838 05839 05840 05841 05842 05843 05844 05900 05901 05902 06000 06001 06002 06003 06004 06005 06006 06007 06008 06009 06010 06011 06012 06013 06014 06015 06016 06017

Control unit/System ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2

SD 812a en-online 05.2007

Fault message Check CSR5 Check CSR5 Check CSR6 Check CSR6 Switch CSR1 bottom pressed Switch CSR1 bottom pressed Switch CSR1 top pressed Switch CSR1 top pressed Switch CSR1 check Switch CSR2 bottom pressed Switch CSR2 bottom pressed Switch CSR2 top pressed Switch CSR2 top pressed Switch CSR2 check Switch CSR4 bottom pressed Switch CSR4 bottom pressed Switch CSR4 top pressed Switch CSR4 top pressed Switch CSR4 check Switch CSR5 bottom pressed Switch CSR5 bottom pressed Switch CSR5 top pressed Switch CSR5 top pressed Switch CSR5 check Switch CSR6 bottom pressed Switch CSR6 bottom pressed Switch CSR6 top pressed Switch CSR6 top pressed Switch CSR6 check Switch CSR7 bottom pressed Switch CSR7 bottom pressed Switch CSR7 top pressed Switch CSR7 top pressed Switch CSR7 check Switch CSR8 bottom pressed Switch CSR8 bottom pressed Switch CSR8 top pressed Switch CSR8 top pressed Switch CSR8 check Speed signal Speed signal fault Speed signal TCO1 message, tachograph ACC Date / time Road speed governing, road speed Instrumentation EBC1 message, EBS ECAS1 message, ECAS ECAM1 message, ECAM EEC1 message, FFR ERC_RD message, secondary retarder ERC_RE message, primary retarder Engine oil pressure Coolant temperature Ambient conditions missing, FFR message FFR EBC2 missing message, EBS EBC3 missing message, EBS EBC4 missing message, EBS Page 271 of 276

SPN 06018 06019 06020 06021

Control unit/System ZBR2 ZBR2 ZBR2 ZBR2

06022 06023 06024 06025 06026

ZBR2 ZBR2 ZBR2 ZBR2 ZBR2

06027

ZBR2

Fault message Engine speed missing ETC1 missing message, FFR ETC2 missing message, FFR ETC3 missing message, FFR Fuel consumption missing, total fuel consumption / consumption since last reset Fuel economy missing, fuel consumption in litres per hour Inlet/exhaust conditions missing, boost pressure information TC1_FT missing, FFR message to automatic gearbox ACC1 message missing, display message from ACC Aux_stat_ZBR_1 not on T-CAN, switch message 1 not on TCAN

06028 06029

ZBR2 ZBR2

Aux_stat_ZBR_1 not on I-CAN, switch message 1 not on I-CAN Dash display/fuel not on I-CAN, cleaning water tank display

06030

ZBR2

ERC1_RX missing, engine brake message missing from FFR

06032

ZBR2

Aux_stat_ZBR_2 not on I-CAN, switch message 2 not on I-CAN

06033

ZBR2

06034

ZBR2

06035

ZBR2

06036

ZBR2

Aux_stat_ZBR_3 not on I-CAN, switch message 3 not on I-CAN Reserved Aux_stat_ZBR_4 not on I-CAN, reserved switch message 4 not on I-CAN Vehicle electrical power not on CAN, voltage term. 30 and 15 from EDC via FFR Retarder_Fluids RD missing, secondary retarder fill level missing

06037 06038 06039 06040

ZBR2 ZBR2 ZBR2 ZBR2

Retarder_Fluids RE missing, primary retarder fill level missing EEC2 message missing, electronic engine check 2 missing Transmission_Fluids missing, gearbox fill level Vehicle weight (EBS) missing, rear axle load (EBS) missing

06041

ZBR2

Vehicle weight (ECAS) missing, vehicle weight (ECAS) missing

06042 06043 06044

ZBR2 ZBR2 ZBR2

06045 06046 06047 06048 06050

ZBR2 ZBR2 ZBR2 ZBR2 ZBR2

06051 06052 06053 06054 06055 06056 06057

ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2

No engine configuration (multipacket), no engine configuration SPN reply message (MAN request) not on I-CAN SPN reply message (MAN request) not on I-CAN ECAM1 message not on T-CAN (ECAM auxiliary function only), reservoir pressures not on T-CAN Torque converter and clutch system (WSK) no message T-CAN fault: VDC1 message could not be received I-CAN ETC2 no message DM-1 ZBR2 message could not be sent (I-CAN) DM-1 message vehicle error memory and data memory (OBDU) could not be sent I-CAN error: No chassis number message T-CAN error: KSM2 message could not be received Vehicle weight message from EBS could not be sent ECAS message failure (ASC1_A) ECAS message failure (RGE21) I-CAN error: No door check message

06058 06059 06060 06061 06062 06110 06111

ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBRO ZBRO

Aux_stat_Inst_2 not on I-CAN Switch message 2 not on I-CAN ESP message failure ECAS message failure (ASC3) height information Vehicle weight message from ECAS could not be sent Vehicle weight message from EBS could not be sent Status IKN active Status node 1.1 fault number

SD 812a en-online 05.2007

Page 272 of 276

SPN 06112 06113 06114 06115 06116 06117 06118 06121 06122 06123 06124 06125 06126 06127 06128 06202 06203 06204 06205 06206 06207 06208 06209 06250 06251 06280 06281 06302 06303 06304 06305 06320 06321 06322 06323 06324 06325 06326 06327 06328 06329 06393 06394 06395 06396 06397 06400 06401 06402 06403 06500 06501 06502 06600 06601 06602 06603 08000 08001 08002

Control unit/System ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBR2 ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO

SD 812a en-online 05.2007

Fault message Status node 1.2 fault number Status node 1.3 fault number Status node 1.4 fault number Status node 1.5 fault number Status node 1.6 fault number Status node 1.7 fault number Status node 1.8 fault number Status node 2.1 fault number Status node 2.2 fault number Status node 2.3 fault number Status node 2.4 fault number Status node 2.5 fault number Status node 2.6 fault number Status node 2.7 fault number Status node 2.8 fault number I-CAN fault: Aux_stat_ZBR_2 message could not be sent I-CAN fault: Aux_stat_ZBR_3 message could not be sent I-CAN fault: Modified message ETC2 could not be sent I-CAN fault: Dash Display message could not be sent T-CAN fault: ECAM1 message could not be sent I-CAN fault: ECAM1 message could not be sent I-CAN fault: DM1 ZBR2 message could not be sent I-CAN fault: DM1 OBDU message could not be sent no CAN message buffer CAN message not evaluated ROM test (program code) incorrect ROM test (EOL parameters) incorrect Serial communication T CAN ground T-CAN warning level, temporary fault T-CAN I-CAN warning level, temporary fault I-CAN Status EBS (T-CAN) fault number Status engine control (T-CAN) fault no. Status gearbox (T-CAN) fault no. Status MTS fault number Status retarder (T-CAN) fault no. Status ECAS (T-CAN) fault number Status door 1 (K3-CAN) fault number Status door 2 (K3-CAN) fault number Status door 3 (K3-CAN) fault number Status door 4 (K3-CAN) fault number Status K3-CAN fault no. (new: 01673) Status FFR (T-CAN) fault number Status ECAS2 (T-CAN) fault number Status CBR2 (T-CAN) Status ECAM (T-CAN) Monitor Monitor Reversing camera Reversing camera Snow chains Snow chains Emergency exit window Galley Coffee machine Toilet Winter package Oil separator Oil separator middle of vehicle Oil separator rear Page 273 of 276

SPN 08003 08004 08005 08006 08007 08008 08009 08010 08010 08010 08011 08011 08012 08013 08014 08020 08100 08100 08101 08101 08101 08101 08102 08102 08103 08103 08103 08103

Control unit/System ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ZBRO ECAM ZBR2 ZBRO ECAM ZBRO ECAM ECAM ECAM ECAM ECAM ZBRO ECAM INST STON ZBRO ECAM ZBRO ECAM INST STON ZBRO

08104 08104

ECAM INST

08104 08104 08104 08105

STON ZBR2 ZBRO INST

08105 08105 08106 08106 08106 08107 08107 08107 08108 08108 08108 08109 08109 08109

STON ZBRO INST STON ZBRO INST STON ZBRO INST STON ZBRO INST STON ZBRO

08110 08110 08110 08111

INST STON ZBRO INST

08111 08111 08112

STON ZBRO INST

SD 812a en-online 05.2007

Fault message Reservoir pressure BK1 too low Reservoir pressure BK2 too low Reservoir pressure BK4 too low Reservoir pressure BK2 sensor defective Reservoir pressure BK1 sensor defective Res. pres. BK2 sensor def. or. n.c Res. pres. BK1 sensor def. or. n.c Pressure below warning level Pressure below warning level Res. pres. BK1 too low or sensor def. Initial filling of circuit 1 – faulty Res. pres. BK1 too low or sensor def. Initial filling of circuit 2 – faulty Initial filling of circuit 3 – faulty Initial filling of circuit 4 – faulty No valid fault definition Control unit defective; ROM checksum incorrect Door 2 photoelectric barrier/sensor Control unit defective; RAM fault Total failure of CAN messages Failure of all CAN messages, but no BUSOFF Door 2 photoelectric barrier/sensor Control unit defective; calibration data checksum incorrect Door 4 photoelectric barrier/sensor Control unit defective; parameter data checksum incorrect CAN message tachograph: Speed and daily mileage counter Failure of message TCO1 (speed, reset trip counter) Door 4 photoelectric barrier/sensor Pressure, pressure sensor – preliminary circuit/pressure regulator CAN message tachograph: Route information Failure of Vehicle Distance message (trip mileage counter, total mileage counter) Previous circuit Door 1, safety strip CAN message tachograph: Date / time Failure of Time Date message (time information from tachograph) Door 2, safety strip CAN message ECAM: Brake pressure pickup (ECAM1) Failure of ECAM1 message (reservoir pressures for brake) Door 3, safety strip CAN message central on-board computer: Tank content Failure of Dash Display/Fuel Level message Door 4, safety strip CAN message EDC: Cooling water temperature Failure of Engine Temperature message Door 1 emergency tap cover open CAN message gearbox control unit: Gear display (ETC2) Failure of ETC2 message (gear information) Door 2 emergency tap cover open CAN message gearbox control unit: Display of splitter group (gear symbol, ETC3) Failure of ETC3 message (splitter group) Door 3 emergency tap cover open CAN message EDC: Boost pressure Failure of Inlet/Exhaust Conditions message (boost pressure bar) Door 4 emergency tap cover open CAN message EDC: Engine speed Page 274 of 276

SPN 08112 08112

Control unit/System STON ZBRO

08113

INST

08113 08113 08114

STON ZBRO INST

08114 08114 08115 08116 08117

STON ZBRO INST INST INST

08117 08118

STON INST

08118

STON

08119

INST

08119 08120 08120

STON INST STON

Fault message Failure of EEC1 message (engine speed display) External emergency taps locked CAN message vehicle management computer: Outside temperature Failure of Ambient Conditions message (external temperature display) External emergency taps unlocked Control unit defective (ICOM total failure) Combi-internal: ICOM total failure (internal plug connection between PCBs) Emergency tap locking Display fault Stepping motor zero point Buffer overrun with DM1 fault messages Combi-internal: Processing error when receiving DM1 messages: * Buffer overrun * Timeout error * Sequence number error Control unit defective (EEPROM checksum error) Combi-internal: Checksum error when reading EEPROM during ongoing operation Control unit defective (EEPROM checksum error during initialisation) Combi-internal: Checksum error when reading EEPROM in the initialisation phase Temperature sensor Combi-internal: Temperature outside the permitted range

08121 08121

INST STON

CAN message central on-board computer: Status message 1 Failure of AUX_STAT_1 message

08122 08122

INST STON

CAN message central on-board computer: Status message 2 Failure of AUX_STAT_2 message

08123 08123

INST STON

CAN message central on-board computer: Status message 3 Failure of AUX_STAT_3 message

08124 08124

INST STON

CAN message central on-board computer: Status message 4 Failure of AUX_STAT_4 message

08125 08125

INST STON

CAN message central on-board computer: Status message 5 Failure of AUX_STAT_5 message

08126 08126

INST STON

CAN message central on-board computer: Status message 6 Failure of AUX_STAT_6 message

08127 08127

INST STON

CAN message central on-board computer: Status message 7 Failure of AUX_STAT_7 message

08128 08128

INST STON

CAN message central on-board computer: Status message 8 Failure of AUX_STAT_8 message

08129 08129

INST STON

08130 08130 08131

INST STON STON

08132

STON

CAN message central on-board computer: DM1 body controller Failure of DM1 Body Controller message (monitoring) CAN message EDC: Cruise control vehicle speed for cruise control function (CCVS) Failure of CC/VHS message (cruise control function) Failure of vehicle identification message (chassis number) Failure of Transmission Fluids exclusive message or Transmission Fluids converter and clutch unit message

SD 812a en-online 05.2007

Page 275 of 276

SPN

Control unit/System

08133

INST

08133 08134 08134 08135 08200 08201

STON INST STON STON STON ECAM

08201 08202 08203

STON ECAM ECAM

08204

ECAM

08310 08320

ECAM ECAM

08330

ECAM

08331

ECAM

08340

ECAM

08341

ECAM

08350

ECAM

08351

ECAM

08360

ECAM

08361

ECAM

08370

ECAM

08371

ECAM

08372

ECAM

08380

ECAM

08381

ECAM

08382

ECAM

08390

ECAM

08391

ECAM

SD 812a en-online 05.2007

Fault message Parameter configuration faulty (consistency, plausibility, assignment error) Consistency error/plausibility error in configuration in parameter tables EOL parameter content: Error Error in EOL parameter content Failure message tank info 1 (AdBlue fill level) Button fault on multifunctional steering wheel (MFL) Control unit defective; watchdog reset Failure message MFL1 from multifunctional steering wheel (LIN data bus) Heating circuit Temperature circuit Maximum delivery volume without regeneration exceeded after completion of first fill CAN data bus driveline, receive time overrun in message 'Wheelbased vehicle speed' from VMC CAN data bus driveline, bus off CAN data bus driveline, receive time exceeded in TCO1 message from tachograph CAN data bus driveline, values in 'TCO1 Vehicle Speed' message from tachograph not plausible CAN data bus driveline, receive time exceeded in EBC1 message from the EBS CAN data bus driveline, values in EBC1 message from the EBS not plausible CAN data bus driveline, receive time violation (too short) in 'Aux_Stat_ZBR_1' message from the central on-board computer CAN data bus driveline, value in 'Aux_Stat_ZBR_1' message from the central on-board computer not plausible CAN data bus driveline, receive time exceeded in 'Ambient_Condition' message from vehicle management computer CAN data bus driveline, values in 'Ambient air temperature' message from vehicle management computer not plausible CAN data bus driveline, receive time exceeded in 'EEC1' message from the EDC CAN data bus driveline, values in 'EEC1 - act_engine_torque' message from the EDC not plausible CAN data bus driveline, values in 'EEC1 - engine_speed' message from the EDC not plausible CAN data bus driveline, receive time exceeded in 'Time/Date' message from tachograph CAN data bus driveline, values in 'Time/Date - Time parameter' message from tachograph not plausible CAN data bus driveline, values in 'Time/Date - Date parameter' message from tachograph not plausible CAN data bus driveline, receive time exceeded in 'High Resolution Vehicle Distance' message from tachograph CAN data bus driveline, values in 'High Resolution Vehicle Distance' message from tachograph not plausible

Page 276 of 276