CDU-VDU Operating Manual
April 28, 2017 | Author: kishoreprithika | Category: N/A
Short Description
hi...
Description
~J~LJ
satorp
TECNICAS REUNIDAS TR Jubail Refinery DOCUMENT No.: SA-JER-DS011 -TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 1 of 244
OPERATING AND SAFETY MANUAL CRUDE DISTILLATION UNIT TRAIN 1 (UNIT 011)
REV. 01
DATE 16-MAY-2013
DESCRIPTION APPROVED FOR CONSTRUCTION
00
22-FEB-2012
ISSUED FOR REVIEW
DISCIPLINE CODE
DOCUMENT TYPE
UNIT
PRO
MAN
011
CHECKED BY Jose Manuel
pr~
SYSTEM
VED BY echuga
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 2 of 244
INDEX I. INTRODUCTION II. BASIS OF DESIGN II.1. Duty of the unit II.1.1. On stream factor II.1.2. Annual throughput II.1.3. Turndown II.2. Environmental Conditions II.3. Feedstock and Product Specification and Integration Inside Refinery Scheme II.3.1. Feedstocks II.3.2. Products II.4. Battery Limit Conditions II.5. Specifications and Consumptions of Utilities II.6. Specification and Consumptions of Chemical and Catalysts II.6.1. Chemicals II.6.2. Catalyst III. PROCESS DESCRIPTION III.1. Process Theory III.2. Description of Flows III.2.1. Crude Preheat Train III.2.2. Desalter Train III.2.3. Preflash Column III.2.4. Crude Heater III.2.5. Crude Distillation III.2.6. Vacuum Heater III.2.7. Vacuum distillation III.2.8. Sour Water III.2.9. Compressor / Amine Absorber III.2.10. Utilities Section III.3. Process Variables III.3.1. Desalter III.3.2. Preflash Column III.3.3. Atmospheric Column III.3.4. Vacuum Column IV. PREPARATION FOR INITIAL START-UP IV.1. General IV.1.1. Check Lists IV.1.2. Test Sheets IV.1.3. Piping Test (Test Pack) IV.2. Inspection Program IV.2.1. Check List Sheets
5 7 7 7 7 7 8 8 8 8 12 12 13 13 14 15 15 16 17 22 26 31 40 49 58 67 68 72 76 76 77 78 81 83 84 87 88 88 88 102
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 3 of 244
IV.3. Cleaning of Piping and Equipment IV.3.1. Water Flushing IV.3.2. Steam Blowing IV.3.3. Air blowing IV.3.4. Oil Flushing IV.3.5. Chemical Cleaning IV.4. Specific Pre-Start-up Operations IV.4.1. Instrument Loop Test IV.4.2. Electrical Motor Run IV.4.3. Tightness Test IV.4.4. Drying of Piping And Equipment IV.4.5. Purging with nitrogen IV.4.6. Operational Tests IV.4.7. Inter-Departmental Coordination IV.4.8. Utility headers Commissioning IV.4.9. Unit Gas In V. START-UP PROCEDURES VI. NORMAL OPERATION VI.1. Operation of CDU/VDU VI.1.1. Operating Flexibility VI.2. Alternative Operating Modes VI.2.1. VDU Bypass VI.2.2. Light Arabian Crude Case VI.3. Special Checks VI.3.1. Desalter Interface Level VI.3.2. Chemical Injection Systems VI.3.3. PZV Mechanical Interlocks VI.4. Problem during Normal Operation VI.4.1. Off-Spec VGO VI.4.2. Tempered Water VI.4.3. Failure of Boiler Feed Water Valves Associated to Desuperheaters VI.4.4. Heat Exchanger Leakage Control VI.4.5. Hydrocarbon in Sour Water Recovery Drum VI.5. Maintenance VI.5.1. Thermal Relief Valves VI.5.2. Control Valves VI.5.3. Cooling Water System VI.5.4. Steam-out VI.5.5. Blind Position VI.5.6. Drainage of Residue to Closed Drain VI.6. Corrosion VI.6.1. Corrosion Mechanism VI.6.2. Inspection VI.6.3. Corrosion Probes and Injection Points VII. NORMAL SHUTDOWN PROCEDURE
126 126 129 132 134 136 141 143 149 153 157 163 164 169 169 171 172 173 173 173 174 174 174 175 175 176 178 178 178 179 179 179 180 180 181 181 181 181 182 182 183 183 183 183 185
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 4 of 244
VIII. EMERGENCY SHUTDOWN PROCEDURES IX. UPSETS SCENARIOS X. ANALYTICAL REQUIREMENTS X.1. Sample Schedule X.2. Analyzers X.3. Sample Connections for Monitoring XI. PLANT SAFETY AND ENVIRONMENTAL PROTECTION XI.1. Toxic Hazards XI.2. Fire Hazards XI.2.1. General Information about Flammable Theory XI.2.2. List of Flammable Limits, Self Ignition Temperature and Flash Point streams and Chemicals present in the Unit XI.2.3. General HSE Precautions to avoid the Flammable Conditions XI.2.4. List of Fire Scenarios XI.2.5. List of Specific Flame, Leak, Heat or Gas Detectors and Relative Control Systems or Fire Fighting Systems Provided, If Any. XI.2.6. Number & Design of Fire Water Monitors, Lances and Hydrants. Plot plan and Coverage Area and List. Idem for Steam Lances XI.2.7. Localization and Capacity and Purpose (Electricity, Hydrocarbons, Multi Purpose) of Extinguishers (Plot plan and List) XI.2.8. Localization and Coverage Area of Flashing Light and Sirens (for Gas, H2S or Fire Detection) XI.3. Personal Protective Equipment XI.4. Emergency XI.5. Health & Environment XI.6. Flare XII. ATTACHMENTS
186 187 188 188 201 204 205 205 207 207 218 220 222 222 226 228 230 230 232 232 233 234
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 5 of 244
I. INTRODUCTION This Operation and Safety Manual, prepared by TR JUBAIL REFINERY intends to capacitate and assist operators for the start-up, operation, shutdown and maintenance of the Crude and Vacuum Distillation Unit (CDU/VDU) included in the Jubail Export Refinery located at Al-Jubail on the east coast of the Kingdom of Saudi Arabia. This document will allow personnel to operate the plant in an efficient and safe way as long as a smooth and stable operation is being carried out. Severe or modified guarantee conditions may lead to lack of accuracy or of applicability in correlations and guidelines stated in this operation manual. This Manual describes the procedures that are required to start, operate and stop the Crude and Vacuum Distillation Unit. The instructions contained herein are presented as a general guide to aid in safe start-up and operation of the unit. Operating experience will indicate where a procedure should be modified to improve the performance of the unit. All the operating personnel must be familiarized with the operation details as well as with the characteristics, function and location of all equipment and instrumentation, to assure the proper unit operation in a safe and efficient way. The Crude Distillation Unit processes the Arabian Heavy Crude from storage and the Wild Naphtha produced by the Low and High pressure HDS Units. The crude is processed into two parallel and identical trains (011 & 012) of integrated atmospheric and vacuum distillation units. Each train is designed to process a net throughput of 200000 BPSD of crude. The required turn-down of each of the CDU/VDU train will be 60%. The Crude Distillation Unit produces and provides the feeds to the following units: •
Straight run Naphtha as feed of the Naphtha Hydrotreating Unit (NHDT).
•
Straight run kerosene, as feed of one of the two Low Pressure HDS units for either jet A1 or diesel production.
•
Light Atmospheric Gas Oil (LAGO) as feed of one of the two Low Pressure HDS units for diesel production.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 6 of 244
•
Heavy Atmospheric and Light Vacuum Gas Oil (HAGO+LVGO) as feed of High Pressure HDS units for diesel production
•
Vacuum Gas Oil (MVGO+HVGO) as feed of the DHC and the MHC units.
•
Vacuum residue as feed of the Coker unit.
Each Crude and Vacuum Distillation Unit comprises mainly the following sections: •
Crude Preheat Train, increases the crude feed temperature using the heat from pumparounds, distillated products, overheads and vacuum residue
•
Desalters, remove salt content from crude by mixing with wash water and a demulsifier
•
Preflash Column, separates the excess of the light components from the crude
•
Crude distillation, including crude heater and atmospheric column with fractionation and pumparound sections to produce Naphtha, Kerosene, LAGO, HAGO and Atmospheric Residue.
•
Vacuum Distillation, consisting of a heater and wet vacuum distillation column, equipped with pre-condenser + ejectors driven by superheated MP steam, to produce LVGO, MVGO+HVGO and Vacuum Residue.
•
Sour Water System, collects process water from the atmospheric and vacuum overheads is sent to SWS Unit (OSBL) before being used as desalting water. The salted water is then sent to WWT unit.
•
Compressor and Amine Absorber, compress and remove H2S of sour gas from ejector system to feed the vacuum heater.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 7 of 244
II. BASIS OF DESIGN II.1. Duty of the unit The Crude Distillation unit is designed to process 400000 BPSD of Arabian Heavy crude from storage and produce: •
Straight run Naphtha
•
Straight run Kerosene
•
Light Atmospheric Gas Oil
•
Blend of Heavy Atmospheric Gas Oil and Light Vacuum Gas Oil
•
Vacuum Gas Oil (VGO)
•
Vacuum residue
The crude is processed into two parallel and identical trains of Atmospheric and Vacuum Distillation Units. As such each train is designed to process a net throughput of 200000 BSPD of crude. These design basis are applicable to each one of the two identical units.
II.1.1. On stream factor The unit shall be designed for an on-stream factor of 8400 hours per year (96% on stream factor). II.1.2. Annual throughput The unit is designed to process an average of 9.9 Million Tonnes per Annum (MTA) of either of design feedstock defined later under feedstock characteristics on section II.3.1. II.1.3. Turndown The required turn-down of each of the CDU/VDU train will be 60%.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 8 of 244
II.2. Environmental Conditions The climatic conditions basic data is derived from: •
JERES-A-112
•
RC meteorological & hydro design information – May 2002 (Attachment A)
For more details, refer to JERES-C-101 Basic Design Data.
II.3. Feedstock and Product Specification and Integration Inside Refinery Scheme
II.3.1. Feedstocks
The definition of the crude quality is as provided by TOTAL Research Center of Gonfreville (CReG) from the standard analysis of the crude. A document generated by TOTAL SOG department (i.e quality of short cuts) from the crude analysis has been used as input of the PRO-II simulations to characterize crude quality. See Attachment 11. Pure components shall also been used for the definition of the PI-145 crude cut (See Attachment 11), in order to provide the components breakdown of the SR Naphtha cut PI-145 sent to the NHDT unit (breakdown required for NHDT/CCR units design). Wild Naphtha from HDS has been defined following data received from Licensors. Total wild naphtha flow rate is equally split between the two CDU/VDU units. For Wild Naphtha flow and composition see Attachment 11.
II.3.2. Products
The following cuts from atmospheric and vacuum distillation are to be produced:
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 9 of 244
•
Unstabilized Whole Naphtha (combined overhead of the preflash and atmospheric distillation columns) as feed of the Naphtha Hydrotreating Unit (NHDT).
•
Kerosene, as feed of one of the two Low Pressure HDS units for either jet A1 or diesel production
•
Light Atmospheric Gas Oil (LAGO), as feed of one of the two Low Pressure HDS units for diesel production.
•
Heavy Atmospheric Gas Oil (HAGO) and Light Vacuum Gas Oil (LVGO), as feed of one of the two High Pressure HDS units for diesel production
•
Medium Vacuum Gas Oil (MVGO) and Heavy Vacuum Gas Oil (HVGO) as feed of the DHC and the MHC units.
•
Vacuum residue as feed of the Coker unit.
II.3.2.1. Cut Points and Flexibility Cases Following optimization studies carried out during the Conceptual study, the Base Case cutpoints are as follows (TBP cut points in °C). Unstabilized Whole Naphtha
IBP – 145
Kerosene
(KERO)
145 – 230
Light Atmospheric. Gas Oil
(LAGO)
230 – 300
Heavy Atmospheric Gas Oil
(HAGO)
300 – 360
Light Vacuum Gas Oil
(LVGO)
360 – 379
Medium Vacuum Gas Oil
(MVGO)
379 – 442
Heavy Vacuum Gas Oil
(HVGO)
442 – 550
Vacuum residue
550+
Additionally, three flexibility cases have be considered for the design: 1. Max Kero: Naphtha / KERO TBP cut point is decreased to 140°C, to saturate the flash point specification of the Kero (ABEL Flash Point ≥ 38°C).
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 10 of 244
2. Max Naphtha: Naphtha / KERO TBP cut point is increased to 160°C, as a result of the optimisation study on gasoline pool (PI-160°C pure components breakdown will be also provided for CCR / NHDT design). 3. Kerosene in diesel pool : LVGO/MVGO cut point will be maximized in respect with both following specifications: Combined Kero, Light and Heavy Atmospheric Gas Oil, and Light Vacuum Gas Oil cuts ASTM D86 95%vol. ≤ 360°C Flash Point Pensky Martens > 55°C II.3.2.2. Fractionation Efficiency Requirements The table below summarizes the target values, following optimization studies carried out during the Conceptual phase: Specification
Units
Target value
Naphtha / Kerosene gap
°C
20 min
Kero / LAGO overlap
°C
10 max
LAGO / HAGO overlap
°C
18 max
II.3.2.3. Product Specifications The product specifications are as follows: •
Kerosene: o Flash point ABEL ≥ 38°C (ASTM D3828) o Freezing point: ≤ -47°C (ASTM D2386) o Distillation FBP :≤ 300°C (ASTM D86) o Other jet A1 specifications (with the exception of bright/clear/water and sulfur specifications which will be handled in the LP HDS unit).
•
Diesel straight run pool: o Combined Light, Heavy Atmospheric Gas Oil, and Light Vacuum Gas Oil cuts
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 11 of 244
ASTM D86 95%vol. ≤ 360°C
Light Atmospheric Gasoil:
Flash point Pensky Martens > 55ºC
o In case Kerosene is incorporated to Diesel pool, LVGO / MVGO TBP cut point will be maximized in respect with both following specifications: Combined Kero, Light and Heavy Atm Gas Oil, and Light Vacuum Gas Oil cuts
•
ASTM D86 95%vol. ≤ 360°C
Flash Point Pensky Martens > 55°C
Straight run MVGO+HVGO: (target values) o Metals content (Nickel, Vanadium) < 2 ppm wt o Conradson Carbon Residue < 1wt% o Asphaltens C7 < 500 ppm wt o ASTM D1160 5%vol. MVGO ≥ 370°C
II.3.2.4. Input Data for Product Properties Calculation The following product properties shall be calculated from the mini-cuts properties (SOG files) and correlations provided by Company (see CDU/VDU - Conceptual study – Final report). •
Thermodynamic properties (boiling point, density, molecular weight),
•
Transport properties (kinematic viscosity@50°C and @100°C),
•
Petroleum properties (flash point ABEL, smoke point, cloud point, pour point, freezing point, Conradson Carbon)
•
Component distribution (PNA, Sulfur, Vanadium, Nickel, total and basic Nitrogen)
II.3.2.5. Expected Product Properties The expected product properties are provided for the following streams:
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 12 of 244
•
Unstabilized Naphtha
•
Kerosene
•
Light atmospheric gasoil
•
Heavy atmospheric gasoil
•
Light vacuum gasoil
•
Medium vacuum gasoil
•
Heavy vacuum gasoil
•
Vacuum residue
•
Light atmospheric gasoil + Heavy atmospheric gasoil + Light vacuum gasoil
•
Medium vacuum gasoil + Heavy vacuum gasoil
Required properties for each cut are provided using the tables provided in Attachment 11. Expected product properties can be found on FEED document: CDU/VDU Expected product Properties, 2271-011-CN-0001-02, included in Attachment 11
II.4. Battery Limit Conditions For process battery limit conditions, refer to Attachment 9 - Process Battery Limit Conditions For utility battery limit conditions, refer to Attachment 10 - Utilities Battery Limit Conditions
II.5. Specifications and Consumptions of Utilities Refer to the Attachment 7 – Utilities Material Balance
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 13 of 244
II.6. Specification and Consumptions of Chemical and Catalysts
II.6.1. Chemicals The following chemicals are required in the daily operation of CDU/VDU. Permanent facilities for the injection of the following chemicals are provided Chemical
Commercial Reference
Supplier
Demulsifier
CHIMEC 2820
CHIMEC (SAUDI FAL)
Neutralizing Agent
CHIMEC 1738
CHIMEC (SAUDI FAL)
Corrosion inhibitor
CHIMEC 1054M
CHIMEC (SAUDI FAL)
Phosphate
CHIMEC 3665
CHIMEC (SAUDI FAL)
DIETHANOLAMINE
NASSAQ (U.I.C)
DEA
II.6-1: List of Chemicals for CDU/VDU
De-emulsifying Agent Type: CHIMEC 2820 or equivalent. Chemical description: Alkoxylated resin in a high boiling hydrocarbon solvent mixture. It is injected at the Crude Charge Pumps suction and Desalter inlets in order to aid separation of any oil/water emulsions that cannot be resolved by electrostatic action alone. •
Rate of Consumption at Charge Pump 011-G-0001 suction: 0.045 m3/h.
•
Rate of Consumption at upstream 1st and 2nd Stage Desalters: 0.030 m3/h.
Neutralizing Agent Type: Chimec 1738 or equivalent. Chemical description: Blend of aminic derivates in water solution. It is injected into the preflash overhead line, topping overhead line and vacuum column overhead line in order to neutralize acid gases and assist in the protection of the main column overhead system against corrosion and fouling.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 14 of 244
•
Rate of consumption at preflash overhead line: 0.001 m3/h.
•
Rate of consumption at topping overhead line: 0.004 m3/h.
•
Rate of consumption at vacuum column overhead line: 0.001 m3/h.
Corrosion inhibitor Type: CHIMEC 1054 M or equivalent. Chemical description: condensation products between poliamines and carboxylic acids in diesel oil. It is injected into the preflash overhead line and topping overhead line in order to protect the preflash and atmospheric column overheads systems against corrosion by both chlorides and hydrogen sulphide. •
Rate of consumption at preflash overhead line: 0.001 m3/h.
•
Rate of consumption at topping overhead line: 0.003 m3/h.
Phosphate Type: CHIMEC 3665 or equivalent. Chemical description: Blend of phospho-organic compounds in water solution. It is injected into the boiler feed water to the Steam Generator in order to remove the calcium hardness and maintains the alkalinity of boiler feed water at the desired level. •
Rate of consumption at BFW inlet to D-0011: 0.0012 m3/h max.
For further information of the chemical consumptions and characteristics refer to Attachment 31 – Chemical Summary and Attachment 19 – Material Safety Data Sheet, respectively.
II.6.2. Catalyst No catalysts or inert balls are used in CDU/ VDU.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 15 of 244
III. PROCESS DESCRIPTION
III.1. Process Theory The distillation is a separation process in which a mixture is heated up and separated in several components or fractions by selective boiling and condensation. Each fraction may contain one or more components of similar volatility and other properties. In refinery distillation, a crude oil mixture is heated up in a fired furnace and then fed into a fractionation column. On entering the column, the feed is a partially vaporized. The liquid starts flowing down but the vapor with lower boiling point components separates and rises. As they rise as vapor, they cool with the liquid falling down from top and part of them –enriched in the less volatile components– begins to condensate and descend again. The “lightest” products –those of lower boiling point or higher volatility– exit from the top of the column. The “heaviest” products –those with the highest boiling point– collect and exit from the bottom of the column. In this process, there is no any kind of chemical reactions. The stage at the bottom of the column has the highest pressure and temperature, progressing upwards in the tower, the pressure and temperature decreases for each succeeding stage. The vapour-liquid equilibrium for each feed component in the column reacts in its unique way to the different pressure and temperature conditions at each of the stages. That means that each component establishes a different concentration in the vapour and liquid phases at each of the stages, and this result in the separation of the components. To improve separation, the distillation column is provided with internal contact elements: trays or packing. The trays basic principle is to bubble vapor through a liquid retained by a damming effect on the liquid phase. The packing consists of a metal latticework dispersing the two phases and providing a good exchange area between the fluids circulating in counterflow. Because physical trays or packing are not 100% efficient, a distillation column needs more trays or packing height than the required number of theoretical vapour-liquid equilibrium stages.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 16 of 244
The part located below the feed inlet is called the stripping zone and its objective is to lower the light product content in the residue. The top of the column or rectifying zone is designed to eliminate heavy products from the distillate. The purity of top product can be improved by recycling some of the externally condensed top product liquid as reflux. In a continuous distillation, the system is kept in a steady state. The process variables are controlled by the automatic control system. An atmospheric distillation column operates at a pressure slightly above atmosphere. It produces an overhead fraction which is totally condensed as total naphtha; a kerosene cut; a light atmospheric gasoil cut; a heavy atmospheric gasoil cut and finally the bottoms product (atmospheric residue). All these cuts are processed further in subsequent refining processes. The distillation column produces fractions having boiling ranges. The boiling ranges between any cut and the next cut overlap because the distillation separations are not perfectly sharp. The atmospheric residue is heated and fed to a vacuum distillation column for additional separation of vacuum gas oil. A very small amount of residue will be thermally cracked in the heater. Dilution steam is injected to limit the temperature and reduce coking.
III.2.
Description of Flows
Refer to the Process Flow Diagrams (PFD) for Base Case: Crude Preheat/Preflash (SAJER-DS011-TRJR-450001, SA-JER-DS011-TRJR-450020), Crude Distillation (SA-JERDS011-TRJR-450002), Vacuum Distillation (SA-JER-DS011-TRJR-450003, SA-JERDS011-TRJR-450021) when reading the following descriptions. Refer to the Attachment 2. The CDU/VDU unit will process crude from storage and will provide feeds to the following units: •
Straight run Naphtha as feed of the Naphtha Hydrotreating Unit, NHDT (Unit 111).
•
Straight run Kerosene, as feed of one of the two Low Pressure HDS units for either jet A1 or diesel production (Unit 101/102).
•
Light Atmospheric Gas Oil as feed of one of the two Low Pressure HDS units for diesel production (Unit 101/102).
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 17 of 244
•
Blend of Heavy Atmospheric Gas Oil and Light Vacuum Gas Oil as feed of one of the two High Pressure HDS units for diesel production (Unit 091/092).
•
Vacuum Gas Oil (VGO) as feed of the DHC (Unit 041) and the MHC (Unit 051) units.
•
Vacuum residue as feed of the Coker unit (Unit 021).
SR NAPHTHA
NHDT (UNIT 111) KEROSENE
LP HDS (UNIT 101/102) LAGO CRUDE OIL SLOPS
DESALTER TRAIN
PREFLASH COLUMN
CDU
LP HDS (UNIT 101/102) Gasoil Mode
HAGO
HP HDS (UNIT 091/092)
LVGO MVGO
VDU
DHC (UNIT 041)
HVGO
MHC (UNIT 051) VACUUM RESIDUE
DCU (UNIT 021)
Distillation Scheme
Each Crude and Vacuum Distillation Unit comprises mainly the following sections:
III.2.1. Crude Preheat Train
PFDs: SA-JER-DS011-TRJR-450001 and SA-JER-DS011-TRJR-450020 (Base Case). The Crude Distillation Unit has three trains of heat exchangers to recover the energy available in the system, from pumparounds, distillated products, overheads and vacuum residue, and raise the temperature of the crude oil from BL.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 18 of 244
The crude oil from storage Unit 561 is pumped by the Crude Charge Pumps G-0001 A/B (33.8 barg), through the crude cold preheat train (from BL to the desalter inlet), which comprises the following heat exchangers in series: E-0001, E-0002, E-0003 A-D, E-0004 A/B, E-0005, E-0006, E-0007 A-B/C-D, E-0008 and E-0009 A/B. In this train the temperature of the crude is raised from the BL inlet temperature (range 30 – 50 ºC) up to 150 ºC maximum. Additionally, the CDU/VDU Unit can reprocess up to 5% of the feed rate of slop oil from storage Unit 681. The slops flow rate is controlled by FC-0175 and then, the stream is mixed with crude feed line upstream G-0001 A/B suction line. The unit crude feed rate is normally controlled at Preflash Column C-0001 inlet by FC0006 which acts on FV-0006 in the same line. However, the operator can select, using HS-0009A/B, to control flow rate at G-0001A/B discharge by means of FC-0001 and valve PV-0007. The temperature upstream the Desalter D-0001/ D-0002 is controlled by action of TC0031 on the HAGO bypass valve (TV-0031) of E-0012A/B. The objective temperature is 145 ºC. If the desalter operating temperature is very high the operator can partially bypass the E-0003 A-D crude feed by adjusting valve HV-0001. The purpose of E-0003 A-D crude feed bypass is to reduce the temperature at E0004A/B inlet for increasing the duty transferred in this preflash condenser. The HV0001 valve shall operate closed during normal operation and when the crude oil temperature coming from storage is below of 40 °C, to maintain the temperature at E0004A/B inlet around of 80 ºC. The hand control valve HV-0003 is provided at E-0003A-D inlet to ensure the adequate flow distribution when heat exchanger is bypassed. In normal operation HC-0001 is closed and HC-0003 is open. Minimum stop on HC-0003 has been implemented to allow feed flow rate. Downstream the Desalter D-0001/ D-0002, the crude is pumped by the Desalted Crude Pumps G-0002 A/B to the crude intermediate preheat train, consisting of the following heat exchangers: E-0010A/B, E-0011A/B, E-0012A/B, E-0013, E-0014A-F. This section raises the temperature of the crude oil from 145ºC up to 200 ºC at Preflash Column inlet.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 19 of 244
Heat exchangers E-0011 and E-0012 are arranged in parallel. A ZIC system is used to control flow through each branch, with the objective of splitting and balance the flow to both exchangers. The flow in each stream is regulated by controllers FC-0111A and FC-0111B. The temperature upstream the Preflash Column C-0001 is controlled by action of the TC-0057 on the Vacuum Residue bypass of the E-0018A-D. The target operating temperature is 200 ºC. If the temperature upstream the C-0001 is very high the operator will be able to partially bypass the E-0014A-F Vacuum Residue side by action on HC0008. To protect the pumps in case of very low flow rate, a dedicated flow controller (FC-0002 for G-0001A/B and FC-0061 for G-0002 A/B) opens the spill back control valves of each pump, recirculating the flow to the suction. Reference P&IDs SA-JER-DS011-TRJR-480001 through 480010 SA-JER-DS011-TRJR-480015 through 480019
TAG NUMBER
SERVICE
E-0007A-D KERO PA BYPASS E-00012A/B HAGO PA BYPASS G-0002A/B CRUDE MINIMUM FLOW G-0002A/B CRUDE SUCTION
SA-JER-DS011-TRJR-
FC-0175
SLOPS FROM STORAGE
FC-0001
E-0001 CRUDE INLET
FC-0002-A
G-0001A/B CRUDE MINIMUM FLOW
FC-0139
E-0001 KERO INLET
HC-0001
E-0003A-D CRUDE BYPASS
HC-0003
E-0003A-D CRUDE INLET
TC-0016
E-0004A/B CRUDE BYPASS
FC-0003
C-0002 KERO PA FLOW RATE
PDC-0449
E-0007A-D KERO PA INLET
TC-0024 TC-0031 FC-0061-A PC-0007
P&ID SA-JER-DS011-TRJR480001 SA-JER-DS011-TRJR480002 SA-JER-DS011-TRJR480002 SA-JER-DS011-TRJR480003 SA-JER-DS011-TRJR480004 SA-JER-DS011-TRJR480004 SA-JER-DS011-TRJR480005 SA-JER-DS011-TRJR480008 SA-JER-DS011-TRJR480008 SA-JER-DS011-TRJR480008 SA-JER-DS011-TRJR480010 SA-JER-DS011-TRJR480015
UNITS
SET POINT
t/h
59.0
t/h
1179.3
t/h
563.5
t/h
133.5
t/h
179.2
t/h
1000.1
ºC
110
t/h
580.6
bar
1.5
ºC
122
ºC
148
t/h
664.5
bar
12
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 20 of 244
TAG NUMBER
SERVICE
P&ID
UNITS
SET POINT
t/h
594.6
t/h
594.6
%
50
bar
0.6
bar
1.0
t/h
374
t/h
1189.1
t/h
80
ºC
200
480015 FC-0111-A FC-0111-B FZC-0111
E-0011A/B DESALTED CRUDE BALANCE E-0012A/B DESALTED CRUDE BALANCE E-0011/12 DESALTED CRUDE BALANCE
PDC-0110
E-0012A/B HAGO INLET
PDC-0111
E-0013 LAGO INLET
TC-0112
E-0013 LAGO PA BYPASS
FC-0006 HC-0008 TC-0057
C-0001 DESALTED CRUDE FEED E-0014A-D VAC RES BYPASS C-0001 FEED TEMPERATURE
SA-JER-DS011-TRJR480017 SA-JER-DS011-TRJR480017 SA-JER-DS011-TRJR480017 SA-JER-DS011-TRJR480017 SA-JER-DS011-TRJR480018 SA-JER-DS011-TRJR480018 SA-JER-DS011-TRJR480019 SA-JER-DS011-TRJR480019 SA-JER-DS011-TRJR480019
Table III.2-1: Controllers of Preheat Train Section
TAG NUMBER
SERVICE
PT-0001
G-0001A/B SUCTION
PT-0140
G-0001-A/B SUCTION
FT-0002-A FT-0002-B PT-0002 TT-0001 TT-0170 TT-0003 TT-0030 TT-0045 TT-0388 FT-0061-A FT-0061-B PT-0010
P&ID
E-0009A/B HAGO OUTLET E-0009A/B CRUDE OUTLET E-0009-A/B HAGO OUTLET G-0002A/B CRUDE MIN FLOW G-0002A/B CRUDE DISCHARGE
SA-JER-DS011TRJR-480001 SA-JER-DS011TRJR-480001 SA-JER-DS011TRJR-480002 SA-JER-DS011TRJR-480002 SA-JER-DS011TRJR-480002 SA-JER-DS011TRJR-480002 SA-JER-DS011TRJR-480002 SA-JER-DS011TRJR-480003 SA-JER-DS011TRJR-480010 SA-JER-DS011TRJR-480010 SA-JER-DS011TRJR-480010 SA-JER-DS011TRJR-480015 SA-JER-DS011TRJR-480015
G-0002A/B DESALTED
SA-JER-DS011-
G-0001-A/B CRUDE MIN FLOW G-0001A/B CRUDE MIN FLOW G-0001-A/B CRUDE DISCHARGE G-0001-A/B CRUDE SUCTION G-0001-A/B CRUDE SUCTION E-0001 KERO OUTLET
UNITS
LL
Barg Barg
H
0.5 482.82 460.3
Barg
39
ºC
55
ºC
70
ºC
75
ºC
165
ºC
143
ºC
barg
153 170
t/h t/h
HH
0.9
t/h t/h
L
663.82 597.4 32
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 21 of 244
TAG NUMBER
SERVICE
P&ID
CRUDE DISCHARGE
TRJR-480015
PDT-0122
G-0002A STRAINER
PDT-0127
G-0002B STRAINER
TT-0446 TT-0193 TT-0289
G-0002A/B DESALTED CRUDE SUCTION E-0014A-D VAC RES AFTER BYPASS E-0014A-D DESALTED CRUDE OUTLET
UNITS
SA-JER-DS011TRJR-480015 SA-JER-DS011TRJR-480015 SA-JER-DS011TRJR-480015 SA-JER-DS011TRJR-480019 SA-JER-DS011TRJR-480019
LL
L
H
mbar
100
mbar
100
ºC
150
ºC
210
ºC
190
205
Table III.2-2: Alarms of Preheat Train Section
TAG NUMBER FV-0175 FV-0002 PV-0007
SERVICE
P&ID
SLOPS FROM STORAGE
SA-JER-DS011-TRJR-480001
G-0001A/B MINIMUM FLOW CONTROL G-0001A/B CRUDE TO DESALTER
SA-JER-DS011-TRJR-480002 SA-JER-DS011-TRJR-480002
HV-0001
E-0003A-D CRUDE BYPASS
SA-JER-DS011-TRJR-480004
HV-0003
E-0003A-D CRUDE INLET
SA-JER-DS011-TRJR-480004
TV-0016
E-0004A/B CRUDE BYPASS
SA-JER-DS011-TRJR-480005
FV-0003
C-0002 KERO PA FLOW RATE
SA-JER-DS011-TRJR-480008
PDV-0449
E-0007A-D KERO PA INLET
SA-JER-DS011-TRJR-480008
TV-0024
E-0007A-D KERO PA BYPASS
SA-JER-DS011-TRJR-480008
FV-0061
G-0002A/B CRU MIN FLOW
SA-JER-DS011-TRJR-480015
FV-0109 FV-0110
E-0012A/B DESALTED CRUDE BALANCE E-0011A/B DESALTED CRUDE BALANCE
SA-JER-DS011-TRJR-480017 SA-JER-DS011-TRJR-480017
PDV-0110
E-0012A/B HAGO INLET
SA-JER-DS011-TRJR-480017
TV-0031
E-00012A/B HAGO PA BYPASS
SA-JER-DS011-TRJR-480017
PDV-0111
E-0013 LAGO PA INLET
SA-JER-DS011-TRJR-480018
E-0013 LAGO PA BYPASS
SA-JER-DS011-TRJR-480018
TV-0112 FV-0006 HV-0008
C-0001 DESALTED CRUDE FEED 011-E-0014A-D VAC RES BYPASS
SA-JER-DS011-TRJR-480019 SA-JER-DS011-TRJR-480019
Table III.2-3: Control Valve of Preheat Train Section
HH
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 22 of 244
TAG NUMBER
SERVICE
P&ID
PZV-0078-A
SLOPS FROM STORAGE
SA-JER-DS011-TRJR-480001
PZV-0078-B
SLOPS FROM STORAGE
SA-JER-DS011-TRJR-480001
TZV-0013 TZV-0017
CRUDE COLD PREHEAT TRAIN CRUDE INTERMEDIATE PREHEAT TRAIN
SA-JER-DS011-TRJR-480010 SA-JER-DS011-TRJR-480019
Table III.2-4: Relief Valves of Preheat Train Section
III.2.2. Desalter Train
PFD: SA-JER-DS011-TRJR-450001 (Base Case). The crude oil contents inorganic salts that can cause severe corrosion and fouling problems. These salts are removed by emulsifying crude oil with wash water and separating them in the desalter train. The desalter train comprises two stage electrostatic desalting units (1st Stage Desalter D-0001 and 2nd Stage Desalter D-0002 13.5/12.5 barg and 145ºC) operating in series. Normally, both stage desalters are operated in series, but the 1st stage and the 2nd stage desalter may be operated as a single unit if the other desalter is shut down for maintenance. The crude oil feed is injected with wash water and treated with a demulsifier chemical upstream the cold preheat train, to promote desalting through contact of oil and water phases. After heating up the crude oil, this emulsion enters the 1st stage Desalter through an inlet distribution header, where it is resolved by coalescence in a high voltage electrical field and subsequently separated into two phases, crude oil and water. The cleaned oil floats and exits the 1st stage desalter vessel via the outlet tray at the top of the desalter and passes on to the 2nd stage desalter vessel. The water containing the dissolved/wetted impurities (or brine) drops under gravity to the bottom of the desalter where it is removed via the effluent water outlet header. Afterwards, the stream is cooled down to 42 ºC through the E-0032A/B, air cooler A-0006 and E-0033, and finally released to the Waste Water Treatment (Unit 651). The brine flow rate is regulated by valve LDV-0089 which controls the crude/water interface level in the desalter (LDC0089). Before entering the 2nd stage desalter vessel, wash water and demulsifying chemical are injected into the crude oil stream. Then it is fed to the D-0002 through an inlet
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 23 of 244
distribution header, where it is resolved by coalescence in a high voltage electrical field and subsequently separated again. The water drops under gravity to the bottom of the vessel where it is removed and recycled to the 1st stage via the level control valve LDV0092 and Desalter Recirculation Pumps G-0024A/B. The mixing efficiency and hence salt content of the crude product is controlled by mixing valves provided upstream of each desalter, PDV-0005 for the 1st stage and PDV-0006 for the 2nd stage. They operate at constant differential pressure and help to disperse water uniformly in the crude increasing contact between both phases. Operating pressure at desalter outlet is controlled by PC-0007 which acts in a split range on the PV-0007 located upstream of the E-0001, and FV-0006 in the Preflash Column feed. It is essential to maintain the pressure in the desalter to prevent any vaporization of the crude. In case of low pressure in the desalter (pump trip) the PC0007 will override FC-0006, via a low signal selector, and close the control valve FV0006. The operating pressure measure to the pressure controller is manually selected by operator via hand switch HS-0007, pressure is measured from PT-0007 located downstream D-0002, or from D-0001 by the midpoint of PT-0373A/B/C in case D-0002 is out of service. An alternative control for the desalter pressure is given by means of manual selectors HS-0009A and HS-0009B, which will allow operator to control crude flow rate at unit inlet by PV-0007 and control pressure in the crude desalter on FV0006. The desalting or wash water is made of phenolic and non-phenolic stripped sour water, and boiler feed water as back up. These streams feed the Desalting Water Surge Drum D-0007 (50ºC, 1.0 barg). Phenolic stripped water feeds D-0007 (1 barg and 50ºC) under flow control with controller FC-0171. Non-phenolic and Boiler Feed Water streams feed D-0007 under flow control (FC-0059B and FC-0059A respectively), reset by drum level control LC-0067 under split range mode. If level is decreasing, the nonphenolic water is fed to D-0007. In case level continues decreasing in the drum, the split range will allows the BFW to feed it. The desalting water is pumped by the Desalting Water Pumps G-0021A/B. The desalting water is preheated in two exchangers, the E-0024 and E-0032A/B until 115 ºC and sent under flow control to the crude oil feed (upstream the cold preheat train) and to the 2nd stage Desalter inlet by action respectively on the flow control valves FV-0005 and FV-0060. In case of 2nd stage Desalter maintenance the fresh desalting water can be sent to the 1st stage Desalter under flow control by FC-0004.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 24 of 244
The demulsifier chemical is pumped from Demulsifier Drum D-0031 by the Demulsifier Pumps G-0030A/B (to G-0001A/B suction) and G-0031A/B (to E-0009 outlet). The purpose of demulsifier is to help the desalter dehydration and salt removal efficiency, and minimize the oil content in the water effluent. The dosing rate is controlled manually by operator adjusting the pump stroke. Reference P&IDs SA-JER-DS011-TRJR-480010 through 480014 SA-JER-DS011-TRJR-480107 through 480112
TAG NUMBER
SERVICE
P&ID
PDC-0005
D-0001 MIXING VALVE
LDC-0089
D-0001 INTERFACE LEVEL
PDC-0006
D-0002 MIXING VALVE
LDC-0092
D-0002 INTERFACE LEVEL
FC-0004 FC-0005 FC-0060 FC-0059-A FC-0059-B FC-0171 LC-0067 PC-0311
DESALTING WATER TO D0001 DESALTING WATER TO E0001 DESALTING WATER TO D0002 D-0007 BFW FEED D-0007 NON-PHENOLIC WATER FEED D-0007 PHENOLIC STRIPPED WATER FEED D-0007 DESALTING WATER SURGE DRUM D-0007 DESALTING WATER SURGE DRUM
SA-JER-DS011-TRJR480010 SA-JER-DS011-TRJR480011 SA-JER-DS011-TRJR480013 SA-JER-DS011-TRJR480012 SA-JER-DS011-TRJR480107 SA-JER-DS011-TRJR480107 SA-JER-DS011-TRJR480107 SA-JER-DS011-TRJR480112 SA-JER-DS011-TRJR480112 SA-JER-DS011-TRJR480112 SA-JER-DS011-TRJR480112 SA-JER-DS011-TRJR480112
UNITS
SET POINT
bar
0.5
%
50
bar
0.5
%
50
t/h
73.5
t/h
31.5
t/h
73.5
t/h
0
t/h
0
t/h
105.0
%
50
barg
1.0
Table III.2-5: Controllers of Desalter Train Section
TAG NUMBER LDT-0089 LDT-0090 LT-0113 PT-0373-A
SERVICE
P&ID
D-0001 DESALTER INTERFACE LEVEL D-0001 DESALTER INTERFACE LEVEL D-0001 DESALTER LIQUID LEVEL D-0001 1ST STG DESALTER
SA-JER-DS011TRJR-480011 SA-JER-DS011TRJR-480011 SA-JER-DS011TRJR-480011 SA-JER-DS011TRJR-480011
UNITS
LL
% %
5.56
%
35
barg
6.5
L
H
27.8
72.2
HH
94.4
9.0
14.5
15.0
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 25 of 244
TAG NUMBER PT-0373-B PT-0373-C LDT-0092 LDT-0093 LT-0114 PT-0450-A PT-0450-B PT-0450-C FT-0142-A FT-0142-B PDT-0200 PDT-0201 TT-0185 AT-0018 FT-0180-A FT-0180-B LT-0069 PT-0231
SERVICE
P&ID
D-0001 1ST STG DESALTER D-0001 1ST STG DESALTER D-0002 DESALTER INTERFACE LEVEL D-0002 DESALTER INTERFACE LEVEL D-0002 DESALTER LIQUID LEVEL D-0002 2ND STG DESALTER D-0002 2ND STG DESALTER D-0002 2ND STG DESALTER G-0024A/B DISCHARGE G-0024A/B DISCHARGE D-0001 CRUDE MIXING VALVE D-0002 CRUDE MIXING VALVE E-0033 BRINE OUTLET TO BL DESALTING WATER pH G-0021-A/B PRW DISCHARGE G-0021-A/B PRW DISCHARGE D-0007 DESALTING WATER SURGE DRUM D-0007 DESALTING WATER SURGE DRUM
SA-JER-DS011TRJR-480011 SA-JER-DS011TRJR-480011 SA-JER-DS011TRJR-480012 SA-JER-DS011TRJR-480012 SA-JER-DS011TRJR-480012 SA-JER-DS011TRJR-480012 SA-JER-DS011TRJR-480012 SA-JER-DS011TRJR-480012 SA-JER-DS011TRJR-480013 SA-JER-DS011TRJR-480013 SA-JER-DS011TRJR-480010 SA-JER-DS011TRJR-480013 SA-JER-DS011TRJR-480109 SA-JER-DS011TRJR-480111 SA-JER-DS011TRJR-480111 SA-JER-DS011TRJR-480111 SA-JER-DS011TRJR-480112 SA-JER-DS011TRJR-480112
UNITS
LL
L
H
HH
barg
6.5
9.0
14.5
15.0
barg
6.5
9.0
14.5
15.0
27.8
72.2
% %
5.56
%
35
barg
6.5
9
14.5
15.0
barg
6.5
9
14.5
15.0
barg
6.5
9
14.5
15.0
t/h t/h
94.4
27.75 24.98
barg
0.1
barg
0.1
ºC
47
-
5.0
t/h
42.57
t/h
7.5
38.31
%
12.42
barg
0.5
87.58
Table III.2-6: Alarms of Desalter Train Section
TAG NUMBER LDV-0089 PDV-0005 LDV-0092 PDV-0006 FV-0004 FV-0005
SERVICE D-0001 DESALTER INTERFACE D-0001 CRUDE MIXING VALVE D-0002 DESALTER INTERFACE D-0002 CRUDE MIXING VALVE DESALTING WATER TO D0001 DESALTING WATER TO E-
P&ID SA-JER-DS011-TRJR-480010 SA-JER-DS011-TRJR-480010 SA-JER-DS011-TRJR-480013 SA-JER-DS011-TRJR-480013 SA-JER-DS011-TRJR-480107 SA-JER-DS011-TRJR-480107
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 26 of 244
TAG NUMBER
SERVICE
P&ID
0001 FV-0060 FV-0059-A FV-0059-B FV-0171
DESALTING WATER TO D0002
SA-JER-DS011-TRJR-480107
D-0007 BFW FEED
SA-JER-DS011-TRJR-480112
D-0007 NON-PHENOLIC WATER FEED D-0007 PHENOLIC STRIPPED WATER FEED
SA-JER-DS011-TRJR-480112 SA-JER-DS011-TRJR-480112
PV-0311-A
D-0007 BLANKETING
SA-JER-DS011-TRJR-480112
PV-0311-B
D-0007 VENT
SA-JER-DS011-TRJR-480112
Table III.2-7: Control Valve of Desalter Train Section
TAG NUMBER
SERVICE
P&ID
PZV-0001
D-0001 DESALTER
SA-JER-DS011-TRJR-480011
PZV-0002
D-0001 DESALTER
SA-JER-DS011-TRJR-480011
PZV-0003
D-0002 DESALTER
SA-JER-DS011-TRJR-480012
PZV-0004
D-0002 DESALTER
SA-JER-DS011-TRJR-480012
E-0033 CWR SHELL SIDE
SA-JER-DS011-TRJR-480109
TZV-0006 PZV-0049 PZV-0050
D-0007 DESALTING WATER SURGE DRUM D-0007 DESALTING WATER SURGE DRUM
SA-JER-DS011-TRJR-480112 SA-JER-DS011-TRJR-480112
Table III.2-8: Relief Valves of Desalter Train Section
III.2.3. Preflash Column PFD: SA-JER-DS011-TRJR-450020 and SA-JER-DS011-TRJR-450002 (Base Case). After heating up the desalted crude through the intermediate preheat train, this is fed to the Preflash Column C-0001 (3.7/3.9 barg and 137/188 ºC) under flow control by FC0006 which acts on FV-0006. Alternatively, the operator can select to control the crude flow rate by means of FC-0001 with PV-0007, and control pressure in the desalter train by PC-0007 acting on FV-0006. There is the alternative to feed Wild naphtha from HDS Unit into the C-0001 instead of the Atmospheric Column C-0002.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 27 of 244
The Preflash Column C-0001 recovers the light-ends from crude oil to reduce the energy requirements and traffic in the distillation column. The total height of C-0001 is 26710 mm. The bottom section diameter is 7500 mm, and the main section diameter is 4200 mm. It has 19 trays with a stripping and a fractionation zone. The column operating pressure varies from 3.9 barg (bottom) to 3.7 barg (top), and the operating temperature from 188 ºC (bottom) to 137 ºC (top). Medium pressure steam is used as stripping steam in the column. This is injected continuously into the bottom of the column under flow control FC-0007. The normal flow rate is 4.5 t/h. The overhead vapor leaves the top at 137ºC; it is partially condensed through the E0004A/B and directed to the Preflash Reflux Drum D-0003 (at 110 ºC and 3.0 barg). In the D-0003, the naphtha vapor and liquid are separated. The vapor leaving from the D-0003 is partially condensed in two steps by the A-0002AF (air cooler) firstly, and then, it is totally condensed by the E-0021 (cooling water). The liquid Naphtha recovered is mixed with the naphtha from the Atmospheric Column C0002, upstream E-0021, and sent to the Total Naphtha Drum D-0005. The D-0005 operates at 1.8 barg and 43ºC. The preflash and atmospheric naphtha produces the total Straight Run (SR) Naphtha which it is routed to the NHDT Unit by the Naphtha to NHDT Pumps G-0007A/B, under flow control FC-0062, reset by the D-0005 level controller LC-0030. The PC-0021 controls the pressure of the Preflash Reflux Drum D-0003, and therefore the cut point of preflash naphtha; by opening and closing in split range the valves PV0038A/B in the Total Naphtha Drum D-0005. The controller vents non-condensable/gas to the flare or enters fuel gas to maintain the pressure in D-0005 and D-0003. The D0003 pressure will be equals to D-0005 pressure plus the pressure drop of A-0002A-F/ E-0021 coolers and interconnecting pipes. The Total Naphtha Drum D-0005 is provided with the pressure controller PC-0038. This is an override control (with low signal selector) to ensure pressure in D-0005 does not fall below vaporization pressure thus preventing flashing of the naphtha in the drum. Under normal conditions, the lower signal selector selects the pressure from D-0003 for controlling PV-0038A/B valves. But, as the pressure in D-0005 drops the set value (1.4 barg), the selector switches to signal from controller PC-0038. When pressure in D0005 is restored, the control returns to PC-0021 in D-0003.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 28 of 244
The temperature of the Preflash Reflux Drum D-0003 is controlled by TC-0016 bypassing the crude side of E-0004A/B, via TV-0016. If a lower temperature needs to be achieved, the HV-0001 in the E-0003 crude bypass could be manually opened. The liquid naphtha is sent back as reflux to the column C-0001 by the Preflash Reflux Pumps G-0003A/B. The reflux flow rate is under flow control FC-0009, reset by the D0003 level controller LC-0004. The water condensed in the D-0003 is collected in a boot, and then it is routed to Sour Water Recovery Drum D-0006 by gravity flow under interface level control LDC-0008. The topped crude is collected in the bottom of Preflash Column C-0001. Then, it is pumped by the Preflash Bottom Pumps G-0004A/B and preheated through the hot preheat train, which comprises six heat exchangers: E-0015A/B, E-0016A/B, E-0017 A/B, E-0018 A-D, E-0019 A-F and E-0020 A-F. Last, the topped crude is fed to Crude Heater F-0001. The bottom liquid level is controlled by LC-0003, which resets the flow master controllers FC-0014A/ FC-0014B of the Crude heater F-0001. These control the total flow of all the passes through the heater. To protect the pumps G-0004 A/B in the event of very low flow rate, an independent flow controller FC-0008 opens the recirculation valve for returning the crude to the column. Reference P&IDs SA-JER-DS011-TRJR-480020 through 480029 SA-JER-DS011-TRJR-480048 through 480051 SA-JER-DS011-TRJR-480142
TAG NUMBER
SERVICE
LC-0003
C-0001 PREFLASH COLUMN
FC-0008-A
G-0004A/B MINIMUM FLOW
FC-0009-A
G-0003A/B REFLUX DISCHARGE
AC-0021
D-0003 AWS OUTLET
LC-0004
D-0003 PREFLASH REFLUX DRUM
LDC-0008
D-0003 INTERFACE BOOT
PC-0021
D-0003 PREFLASH REFLUX DRUM
P&ID SA-JER-DS011-TRJR480020 SA-JER-DS011-TRJR480021 SA-JER-DS011-TRJR480022 SA-JER-DS011-TRJR480023 SA-JER-DS011-TRJR480023 SA-JER-DS011-TRJR480023 SA-JER-DS011-TRJR480023
UNITS
SET POINT
%
50
t/h
471.2
t/h
54.7 6
%
50
%
70
barg
3.0
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 29 of 244
TAG NUMBER LC-0030 LDC-0032 PC-0038 FC-0062
SERVICE D-0005 TOTAL NAPHTHA DRUM D-0005 INTERFACE BOOT D-0005 TOTAL NAPHTHA DRUM G-0007A/B NAPHTHA TO NHDT
FC-0049
E-0015A/B HVGO INLET
FC-0013
C-0002 HAGO PA RETURN
PDC-0146
E-0017A/B HAGO PA INLET
TC-0079 FC-0063-A FC-0007
E-0017A/B HAGO PA BYPASS C-0003 C-0003 VACUUM RESIDUE QUENCH STRIPPING STEAM TO C0001
P&ID SA-JER-DS011-TRJR480050 SA-JER-DS011-TRJR480050 SA-JER-DS011-TRJR480050 SA-JER-DS011-TRJR480051 SA-JER-DS011-TRJR480024 SA-JER-DS011-TRJR480026 SA-JER-DS011-TRJR480026 SA-JER-DS011-TRJR480026 SA-JER-DS011-TRJR480027 SA-JER-DS011-TRJR480142
UNITS
SET POINT
%
84
%
66
barg
1.4
t/h
152.1
t/h
181.5
t/h
664.6
bar
0.52
ºC
262
t/h
112.2
t/h
4.5
Table III.2-9: Controllers of Preflash Column Section
TAG NUMBER PT-0A PT-0B PT-0C TT-0058 FT-0008-A FT-0008-B PT-0451 FT-0009-B LT-0004 LT-0006 TT-0118 FT-0026 LT-0028 LT-0030
SERVICE
P&ID
C-0001 TOP NAPHTHA OUTLET C-0001 TOP NAPHTHA OUTLET C-0001 TOP NAPHTHA OUTLET C-0001 TOP NAPHTHA OUTLET G-0004A/B MINIMUM FLOW G-0004A/B TOPPED CRUDE G-0004A/B CRUDE DISCHARGE G-0003A/B REFLUX DISCHARGE D-0003 PREFLASH REFLUX DRUM D-0003 PREFLASH REFLUX DRUM E-0021 NAPHTHA OUTLET D-0005 VAPOR TO FLARE D-0005 TOTAL NAPHTHA DRUM D-0005 TOTAL
SA-JER-DS011TRJR-480020 SA-JER-DS011TRJR-480020 SA-JER-DS011TRJR-480020 SA-JER-DS011TRJR-480020 SA-JER-DS011TRJR-480021 SA-JER-DS011TRJR-480021 SA-JER-DS011TRJR-480021 SA-JER-DS011TRJR-480022 SA-JER-DS011TRJR-480023 SA-JER-DS011TRJR-480023 SA-JER-DS011TRJR-480049 SA-JER-DS011TRJR-480050 SA-JER-DS011TRJR-480050 SA-JER-DS011-
UNIT S
LL
H
HH
Barg
4.1
4.5
Barg
4.1
4.5
Barg
4.1
4.5
ºC
142 473.1 3
t/h t/h
L
426.2 9
barg
34.4
t/h
15.61
%
38.89
%
83.3 3
11.11
ºC
48
t/h % %
6.0 76
92
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 30 of 244
TAG NUMBER
PT-0100 LDT-0032 LDT-0033 AT-0013 TT-0195 TT-0389 FT-0063-B TT-0194 TT-0356
SERVICE
P&ID
NAPHTHA DRUM
TRJR-480050
D-0005 TOTAL NAPHTHA DRUM D-0005 INTERFACE BOOT D-0005 INTERFACE BOOT NAPHTHA TO NHDT ASTM D86 95% E-0015A/B HVGO +MVGO INLET E-0015A/B HVGO +MVGO INLET C-0003 VACUUM RESIDUE QUENCH STRIPPING STEAM TO C-0001 STRIPPING STEAM TO C-0001
SA-JER-DS011TRJR-480050 SA-JER-DS011TRJR-480050 SA-JER-DS011TRJR-480050 SA-JER-DS011TRJR-480051 SA-JER-DS011TRJR-480024 SA-JER-DS011TRJR-480024 SA-JER-DS011TRJR-480027 SA-JER-DS011TRJR-480142 SA-JER-DS011TRJR-480142
UNIT S
LL
barg
L
H
0.8
2.9
% % ºC
140
ºC
265
ºC
275
t/h
67.8
ºC
245
ºC
300
205
Table III.2-10: Alarms of Preflash Column Section
TAG NUMBER
SERVICE
P&ID
FV-0008
SA-JER-DS011-TRJR-480021
LDV-0008
G-0004A/B MINIMUM FLOW G-0003A/B REFLUX FLOW RATE D-0003 BOOT INTERFACE
FV-0009
SA-JER-DS011-TRJR-480022 SA-JER-DS011-TRJR-480023
LDV-0032
D-0005 BOOT INTERFACE
SA-JER-DS011-TRJR-480050
PV-0038-A
D-0005 BLANKETING
SA-JER-DS011-TRJR-480050
PV-0038-B
SA-JER-DS011-TRJR-480050
FV-0049
D-0005 VENT G-0007A/B NAPHTHA TO NHDT E-0015A/B HVGO INLET
FV-0013
C-0002 HAGO PA RETURN
SA-JER-DS011-TRJR-480026
PDV-0146
E-0017A/B HAGO PA INLET
SA-JER-DS011-TRJR-480026
TV-0079
E-0017A/B HAGO PA BYPASS C-0003 VACUUM RESIDUE QUENCH E-0018A-D VACUUM RESIDUE BYPASS STRIPPING STEAM TO C0001
SA-JER-DS011-TRJR-480026
FV-0062
FV-0063 TV-0057 FV-0007
HH
SA-JER-DS011-TRJR-480051 SA-JER-DS011-TRJR-480024
SA-JER-DS011-TRJR-480027 SA-JER-DS011-TRJR-480027 SA-JER-DS011-TRJR-480142
Table III.2-11: Control Valve of Preflash Column Section
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 31 of 244
TAG NUMBER PZV-0005-A PZV-0005-B PZV-0006 PZV-0007 PZV-0008 TZV-0001 PZV-0014 PZV-0015
SERVICE C-0001 PREFLASH COLUMN C-0001 PREFLASH COLUMN C-0001 PREFLASH COLUMN D-0003 PREFLASH REFLUX DRUM D-0003 PREFLASH REFLUX DRUM E-0021 CWR TUBE SIDE D-0005 TOTAL NAPHTHA DRUM D-0005 TOTAL NAPHTHA DRUM
P&ID SA-JER-DS011-TRJR-480020 SA-JER-DS011-TRJR-480020 SA-JER-DS011-TRJR-480020 SA-JER-DS011-TRJR-480023 SA-JER-DS011-TRJR-480023 SA-JER-DS011-TRJR-480049 SA-JER-DS011-TRJR-480050 SA-JER-DS011-TRJR-480050
Table III.2-12: Relief Valves of Preflash Column Section
III.2.4. Crude Heater
PFD: SA-JER-DS011-TRJR-450002 (Base Case). The topped crude enters into the Crude Heater F-0001, where is heated up to 366 ºC and partially vaporized until 33%wt for the atmospheric distillation. The F-0001 consists of two radiant cells and a common convection section above the arch. It is equipped with 20 hearth burners in total, 10 burners in line per cell. Low NOx burners are used. The heater is fired with fuel gas and is designed to reach a minimum fuel efficiency of 92%. No steam/air decoking system is required, only pigging facilities are provided. The crude is routed to two cells and divided into eight passes (four passes per cell). The flow control on each pass, FC-00015 A-H, is designed to maintain a variable distribution of mass flow into each pass with two objectives: achieve an overall fired heater flow set point and achieve equal pass outlet temperature. The software signal from each FC (dedicated to each pass) is sent in case of passes from A to D to one summing device and for passes E to H to another summing device to totalize and average the total flow. The two generated total average flow software signal (FC0014A/FC-0014B) are reset by the level controller signal of the Preflash Column (LC0003).
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 32 of 244
At the heater outlet the four passes are routed as individual branches to the transfer line. The average temperature of the four process outlets of each cell is controlled by temperature controllers (TC-0097AA/TC-0097BA) which set the setpoint of the demand controller FC-0069/FC-0076 for cell A and cell B respectively and the air /fuel ratio system control. In order to prevent the fuel gas pressure lower than the safety level, the signal from heat demand controller FC-0069/0076 is overridden by the minimum pressure controller PC-0136B/0196B via the high selector PY-0136/0196 which manipulate the control valve FV-0069/0076. During start-up operation, the fuel gas pressure is controlled by PC-0136A/0196A which manipulate the small control valve PV-0136/0196 for cell A and cell B respectively. A correct air/fuel ratio (or excess O2) is essential for energy efficient operation. In the crude heater, the O2 concentration is measured and controlled by AC-0001 and AC0002 which regulates the air/fuel ratio for cell A and cell B respectively. The low air/fuel ratio alarm will alert the operator to correct in order to avoid sub-stoichiometric firing. Furthermore, the low-low air/fuel ratio will activate the minimum firing trip on the heater. The air flow controller FC-0074/0070 is the main tool to control the desired air/fuel ratio. Heat demand controllers 011-FC-0069/0076 manipulate the FV´s. To prevent the main fuel pressure dropping below the minimum pressure, one pressure controller per cell PC-0136B/0196B will override the heat demand controller output in case the pressure is lower than the setpoint. The dampers PV-0395A/B in the two takeoffs to the stack operate as one; they are used to control a slight negative arch pressure by PC-0395, regulating the pass of the flue gases. The flue gases from the Crude and Vacuum Heaters (F-0001/ F-0002) are joined together and routed to an air preheat system. To recover heat from the flue gas, the air preheat system is provided with three Combustion Air Forced fan (K-0002 A/B/C), one Flue Gas Induced Fan (K-0003), a Steam/Air Preheater (011-E-0041), and an Air Preheater (E-0040) to transfer the heat from the flue gas to the combustion air. The air enters K-0002 A/B/C (two operating and one spare); through the Air Filter S-0013A-D, passes through the air preheating system, and it is divided into four streams for cell A and B of the crude and vacuum heaters. These streams are controlled by the Fuel/Air Ratio System using the flow venturis and dampers en each line. Therefore, the combustion air flow will maintain ratio to the fuel gas flow.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 33 of 244
The temperature at Steam/Air Preheater outlet is controlled by TC-0223 which manipulates the control valve TV-0223 in the steam side. The skin metal temperature of the Air Preheater E-0040 is measured by TI-0032A/B/C in three different locations. The lowest of the three temperatures is controlled by TC0032 which manipulates the bypass control valve of air preheater. At the air preheater outlet header the air pressure is measured and controlled by PC-0160 which sets and equal opening to the suction throttle dampers PV-0160A/B/C of running forced draft fans (K-0002 A/B/C). The flue gas from both cells is routed to a common stack located on top of F-0001, usually operating on balanced draft. A damper in the stack allows flue gas bypass around the Air Preheater E-0040 and K-0003, with the objective of keeping the heaters running in case K-0003 or E-0040 failure, operating then in forced draft. Normally the Flue Gas Induced Fan (K-0003) is used to create a draft at the base of stack. The stack damper HV-0015 is normally closed. Stack base draft is controlled by PC-0159 throttling the K-0003 suction valve PV-0159. In case of failure of the ID fan, the UC-0332 will switch balanced draft to forced draft mode. Part of the F-0001 convection section is used also to superheat Low Pressure Steam from LPS header. This is used as stripping steam in the Atmospheric Column (C-0002), HAGO Stripper (C-0006) and LAGO Stripper (C-0005). The Desuperheater DS-0001 has been provided to maintain stripping steam temperature from F-0001 to column C-0002, C-0005 and C-0006 at 350ºC. The temperature downstream of the desuperheater is controlled by action of the controller TC-0043 which acting on BFW control valve TV-0043. Reference P&IDs SA-JER-DS011-TRJR-480030 through 480042 SA-JER-DS011-TRJR-480115 through 480117 SA-JER-DS011-TRJR-480121 SA-JER-DS011-TRJR-480169 and 480270 SA-JER-DS011-TRJR-480311 and 480312
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 34 of 244
TAG NUMBER FC-0015-A FC-0015-B FC-0015-C FC-0015-D FC-0015-E FC-0015-F FC-0015-G FC-0015-H TC-0097-AA TC-0097-A TC-0097-B TC-0097-C TC-0097-D TC-0097-BA TC-0097-E TC-0097-F TC-0097-G TC-0097-H FC-0021 TC-0043 FC-0069 PC-0136-A PC-0136-B FC-0076 PC-0196-A PC-0196-B
SERVICE
P&ID
F-0001 CRUDE PASS 1 INLET F-0001 CRUDE PASS 2 INLET F-0001 CRUDE PASS 3 INLET F-0001 CRUDE PASS 4 INLET F-0001 CRUDE PASS 5 INLET F-0001 CRUDE PASS 6 INLET F-0001 CRUDE PASS 7 INLET F-0001 CRUDE PASS 8 INLET F-0001 CRUDE OUTLET CELL WEST F-0001 CRUDE PASS 1 OUTLET F-0001 CRUDE PASS 2 OUTLET F-0001 CRUDE PASS 3 OUTLET F-0001 CRUDE PASS 4 OUTLET F-0001 CRUDE OUTLET CELL EAST F-0001 CRUDE PASS 5 OUTLET F-0001 CRUDE PASS 6 OUTLET F-0001 CRUDE PASS 7 OUTLET F-0001 CRUDE PASS 8 OUTLET F-0001 STRIPPING STEAM TO C-0002 DS-0001 BFW (STEAM TEMPERATURE) F-0001 FUEL GAS FEED WEST F-0001 FUEL GAS FEED WEST F-0001 FUEL GAS FEED WEST F-0001 FUEL GAS FEED EAST F-0001 FUEL GAS FEED EAST
SA-JER-DS011-TRJR480030 SA-JER-DS011-TRJR480030 SA-JER-DS011-TRJR480031 SA-JER-DS011-TRJR480031 SA-JER-DS011-TRJR480032 SA-JER-DS011-TRJR480032 SA-JER-DS011-TRJR480033 SA-JER-DS011-TRJR480033 SA-JER-DS011-TRJR480034 SA-JER-DS011-TRJR480034 SA-JER-DS011-TRJR480035 SA-JER-DS011-TRJR480036 SA-JER-DS011-TRJR480037 SA-JER-DS011-TRJR480038 SA-JER-DS011-TRJR480038 SA-JER-DS011-TRJR480039 SA-JER-DS011-TRJR480040 SA-JER-DS011-TRJR480041 SA-JER-DS011-TRJR480042 SA-JER-DS011-TRJR480042 SA-JER-DS011-TRJR480115 SA-JER-DS011-TRJR480115 SA-JER-DS011-TRJR480115 SA-JER-DS011-TRJR480116 SA-JER-DS011-TRJR480116
F-0001 FUEL GAS FEED
SA-JER-DS011-TRJR-
UNITS
SET POINT
t/h
138.4
t/h
138.4
t/h
138.4
t/h
138.4
t/h
138.4
t/h
138.4
t/h
138.4
t/h
138.4
ºC
367
ºC
366.5
ºC
366.5
ºC
366.5
ºC
366.5
ºC
367
ºC
366.5
ºC
366.5
ºC
366.5
ºC
366.5
t/h
20.2
ºC
350
t/h
3.302
barg
0.12
barg
2.2
t/h
3.302
barg
0.12
barg
2.2
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 35 of 244
TAG NUMBER
SERVICE
P&ID
EAST
480116
AC-0001
F-0001 FLUE GAS O2%
AC-0002
F-0001 FLUE GAS O2%
PC-0395
F-0001 STACK
FC-0070 FC-0074 HC-0015 PC-0159
COMBUSTION AIR TO F0001 COMBUSTION AIR TO F0001 F-0001/F-0002 HEATERS DRAFT F-0001/0002 HEATERS DRAFT
PC-0160
E-0040 AIR OUTLET
TC-0032
E-0040 FLUE GAS
TC-0223
E-0041 COMB AIR OUTLET
FC-0014-A FC-0014-B FC-0033-A FC-0033-B
F-0001 CRU INLET CELL WEST F-0001 CRU INLET CELL EAST F-0002 ATM RESIDUE CELL WEST F-0002 ATM RESIDUE CELL EAST
SA-JER-DS011-TRJR480117 SA-JER-DS011-TRJR480117 SA-JER-DS011-TRJR480117 SA-JER-DS011-TRJR480121 SA-JER-DS011-TRJR480121 SA-JER-DS011-TRJR480121 SA-JER-DS011-TRJR480121 SA-JER-DS011-TRJR480121 SA-JER-DS011-TRJR480121 SA-JER-DS011-TRJR480121 SA-JER-DS011-TRJR480311 SA-JER-DS011-TRJR480311 SA-JER-DS011-TRJR480312 SA-JER-DS011-TRJR480312
UNITS
SET POINT
%
3
%
3
mmH2O
-2.5
t/h t/h
mmH2O
-13
mmH2O ºC
175
ºC
75
t/h
138.4
t/h
138.4
t/h
83.9
t/h
83.9
Table III.2-13: Controllers of Crude Heater Section
TAG NUMBER FT-0015-AA FT-0015-AB FT-0015-AC FT-0015-BA FT-0015-BB FT-0015-BC FT-0015-CA FT-0015-CB FT-0015-CC
SERVICE
P&ID
F-0001 CRUDE PASS 1 INLET F-0001 CRUDE PASS 1 INLET F-0001 CRUDE PASS 1 INLET F-0001 CRUDE PASS 2 INLET F-0001 CRUDE PASS 2 INLET F-0001 CRUDE PASS 2 INLET F-0001 CRUDE PASS 3 INLET F-0001 CRUDE PASS 3 INLET F-0001 CRUDE PASS 3 INLET
SA-JER-DS011TRJR-480030 SA-JER-DS011TRJR-480030 SA-JER-DS011TRJR-480030 SA-JER-DS011TRJR-480030 SA-JER-DS011TRJR-480030 SA-JER-DS011TRJR-480030 SA-JER-DS011TRJR-480031 SA-JER-DS011TRJR-480031 SA-JER-DS011TRJR-480031
UNITS
LL
L
t/h
55.64
82.96
t/h
55.64
82.96
t/h
55.64
82.96
t/h
55.64
82.96
t/h
55.64
82.96
t/h
55.64
82.96
t/h
55.64
82.96
t/h
55.64
82.96
t/h
55.64
82.96
H
HH
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 36 of 244
TAG NUMBER FT-0015-DA FT-0015-DB FT-0015-DC FT-0015-EA FT-0015-EB FT-0015-EC FT-0015-FA FT-0015-FB FT-0015-FC FT-0015-GA FT-0015-GB FT-0015-GC FT-0015-HA FT-0015-HB FT-0015-HC TT-0097-A TT-0100-A TT-0097-B TT-0100-B TT-0097-C TT-0100-C TT-0097-D TT-0100-D TT-0097-E TT-0100-E TT-0097-F
SERVICE
P&ID
F-0001 CRUDE PASS 4 INLET F-0001 CRUDE PASS 4 INLET F-0001 CRU PASS 4 INLET F-0001 CRUDE PASS 5 INLET F-0001 CRUDE PASS 5 INLET F-0001 CRUDE PASS 5 INLET F-0001 CRUDE PASS 6 INLET F-0001 CRUDE PASS 6 INLET F-0001 CRUDE PASS 6 INLET F-0001 CRUDE PASS 7 INLET F-0001 CRUDE PASS 7 INLET F-0001 CRUDE PASS 7 INLET F-0001 CRUDE PASS 8 INLET F-0001 CRUDE PASS 8 INLET F-0001 CRUDE PASS 8 INLET F-0001 CRUDE PASS 1 OUTLET F-0001 CRUDE PASS 1 OUTLET F-0001 CRUDE PASS 2 OUTLET F-0001 CRUDE PASS 2 OUTLET F-0001 CRUDE PASS 3 OUTLET F-0001 CRU PASS 3 OUTLET F-0001 CRU PASS 4 OUTLET F-0001 CRU PASS 4 OUTLET F-0001 CRU PASS 5 OUTLET F-0001 CRU PASS 5 OUTLET F-0001 CRU PASS 6 OUTLET
SA-JER-DS011TRJR-480031 SA-JER-DS011TRJR-480031 SA-JER-DS011TRJR-480031 SA-JER-DS011TRJR-480032 SA-JER-DS011TRJR-480032 SA-JER-DS011TRJR-480032 SA-JER-DS011TRJR-480032 SA-JER-DS011TRJR-480032 SA-JER-DS011TRJR-480032 SA-JER-DS011TRJR-480033 SA-JER-DS011TRJR-480033 SA-JER-DS011TRJR-480033 SA-JER-DS011TRJR-480033 SA-JER-DS011TRJR-480033 SA-JER-DS011TRJR-480033 SA-JER-DS011TRJR-480034 SA-JER-DS011TRJR-480034 SA-JER-DS011TRJR-480035 SA-JER-DS011TRJR-480035 SA-JER-DS011TRJR-480036 SA-JER-DS011TRJR-480036 SA-JER-DS011TRJR-480037 SA-JER-DS011TRJR-480037 SA-JER-DS011TRJR-480038 SA-JER-DS011TRJR-480038 SA-JER-DS011TRJR-480039
UNITS
LL
L
/h
55.64
82.96
t/h
55.64
82.96
t/h
55.64
82.96
t/h
55.64
82.96
t/h
55.64
82.96
t/h
55.64
82.96
t/h
55.64
82.96
t/h
55.64
82.96
t/h
55.64
82.96
t/h
55.64
82.96
t/h
55.64
82.96
t/h
55.64
82.96
t/h
55.64
82.96
t/h
55.64
82.96
t/h
55.64
82.96
ºC
H
372
ºC ºC
390 372
ºC ºC
390 372
ºC ºC
390 372
ºC ºC
390 372
ºC ºC
HH
390 372
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 37 of 244
TAG NUMBER TT-0100-F TT-0097-G TT-0100-G TT-0097-H TT-0098 TT-0100-H TT-0043 TT-0091 TT-0359 TT-0360 PT-0131 PT-0132 PT-0136 PT-0138 PDT-0142 PDT-0143 PT-0386 PT-0443 PT-0191 PT-0192 PT-0193 PT-0196 PDT-0197 PDT-0198 PT-0390 PT-0393
SERVICE
P&ID
F-0001 CRU PASS 6 OUTLET F-0001 CRU PASS 7 OUTLET F-0001 CRU PASS 7 OUTLET F-0001 CRUDE PASS 8 OUTLET F-0001 CRUDE PASS 1 TO 8 CONNECTION F-0001 CRUDE PASS 8 OUTLET
SA-JER-DS011TRJR-480039 SA-JER-DS011TRJR-480040 SA-JER-DS011TRJR-480040 SA-JER-DS011TRJR-480041 SA-JER-DS011TRJR-480041 SA-JER-DS011TRJR-480041 SA-JER-DS011TRJR-480042 SA-JER-DS011TRJR-480042 SA-JER-DS011TRJR-480042 SA-JER-DS011TRJR-480042 SA-JER-DS011TRJR-480115 SA-JER-DS011TRJR-480115 SA-JER-DS011TRJR-480115 SA-JER-DS011TRJR-480115 SA-JER-DS011TRJR-480115 SA-JER-DS011TRJR-480115 SA-JER-DS011TRJR-480115 SA-JER-DS011TRJR-480115 SA-JER-DS011TRJR-480116 SA-JER-DS011TRJR-480116 SA-JER-DS011TRJR-480116 SA-JER-DS011TRJR-480116 SA-JER-DS011TRJR-480116 SA-JER-DS011TRJR-480116 SA-JER-DS011TRJR-480116 SA-JER-DS011TRJR-480116
DS-0001 BFW F-0001 STRIPPING STEAM OUTLET F-0001 STRIPPING STEAM TO C-0002 F-0001 STRIPPING STEAM TO C-0002 F-0001 FUEL GAS FEED F-0001 PILOT GAS FEED F-0001 FUEL GAS FEED F-0001 PILOT GAS FEED F-0001 PILOT GAS FEED F-0001 FUEL GAS FEED F-0001 FUEL GAS FEED F-0001 PILOT GAS FEED F-0001 PILOT GAS FEED F-0001 PILOT GAS FEED F-0001 FUEL GAS FEED F-0001 FUEL GAS FEED F-0001 PILOT GAS FEED F-0001 FUEL GAS FEED F-0001 FUEL GAS FEED F-0001 PILOT GAS FEED
UNITS
LL
L
H
ºC
HH 390
ºC
372
ºC
390
ºC
372
ºC
361
371
ºC
390
ºC
360
ºC
403
ºC
345
ºC
155
barg
0.05
2.2
barg
0.4
1.4
barg
0.15
1.95
barg
0.6
1.2
bar
0.15
bar
0.15
barg
0.1
4.0
barg
0.1
4.0
barg
0.4
1.4
barg barg
0.6
1.2
0.05
barg
2.2 0.15
1.95
bar
0.15
bar
0.15
barg
0.1
4.0
barg
0.1
4.0
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 38 of 244
TAG NUMBER PT-0150-A
PT-0150-B
PT-0150-C PT-0396 PT-0397-A PT-0397-B PT-0397-C
SERVICE F-0001 CRU HTR RADIANT HEADER BOX F-0001 CRU HTR RADIANT HEADER BOX F-0001 CRU HTR RADIANT HEADER BOX F-0001 CRUDE HEATER F-0001 RADIANT HEADER BOX F-0001 RADIANT HEADER BOX F-0001 RADIANT HEADER BOX
FT-0070-A
COMB AIR TO F-0001
FT-0070-B
COMB AIR TO F-0001
FT-0070-C
COMB AIR TO F-0001
FT-0074-A
COMB AIR TO F-0001
FT-0074-B
COMB AIR TO F-0001
FT-0074-C
COMB AIR TO F-0001
PDT-0156 PT-0158 PT-0161 TT-0032-A TT-0032-B TT-0032-C TT-0225 AT-0040 AT-0045-A AT-0045-B PDT-0394
K-0003 FLUE GAS INDUCED FAN F-0001/ F-0002 HEATERS STACK E-0040 COMBUSTION AIR OUTLET E-0040 FLUE GAS (SKIN) E-0040 FLUE GAS (SKIN) E-0040 FLUE GAS (SKIN) COMB AIR DUCT TO F0001/0002 HEATER AIR FILTER F-0001/ 0002 INTAKE AIR F-0001/ 0002 INTAKE AIR HEATER AIR FILTER
P&ID
UNITS
SA-JER-DS011TRJR-480117
H
HH
mmH2O
-11
-1
SA-JER-DS011TRJR-480117
mmH2O
-11
-1
SA-JER-DS011TRJR-480117
mmH2O
-11
-1
SA-JER-DS011TRJR-480117 SA-JER-DS011TRJR-480117 SA-JER-DS011TRJR-480117 SA-JER-DS011TRJR-480117 SA-JER-DS011TRJR-480121 SA-JER-DS011TRJR-480121 SA-JER-DS011TRJR-480121 SA-JER-DS011TRJR-480121 SA-JER-DS011TRJR-480121 SA-JER-DS011TRJR-480121 SA-JER-DS011TRJR-480121 SA-JER-DS011TRJR-480121 SA-JER-DS011TRJR-480121 SA-JER-DS011TRJR-480121 SA-JER-DS011TRJR-480121 SA-JER-DS011TRJR-480121 SA-JER-DS011TRJR-480121 SA-JER-DS011TRJR-480270 SA-JER-DS011TRJR-480270 SA-JER-DS011TRJR-480270 SA-JER-DS011TRJR-480270
LL
mmH2O
L
-10
0
mmH2O
-11
-1
mmH2O
-11
-1
mmH2O
-11
-1
t/h
17.13
24.47
t/h
17.13
24.47
t/h
17.13
24.47
t/h
17.13
24.47
t/h
17.13
24.47
t/h
17.13
24.47
mmH2O
10
mmH2O
-30
mmH2O
20
ºC
123
ºC
123
ºC
123
ºC
170
0
230 95
bar
Table III.2-14: Alarms of Crude Heater Section
1
10
1
10
0.013
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 39 of 244
TAG NUMBER
SERVICE
P&ID
FV-0015-A
F-0001 CRUDE PASS 1 INLET
SA-JER-DS011-TRJR-480030
FV-0015-B
F-0001 CRUDE PASS 2 INLET
SA-JER-DS011-TRJR-480030
FV-0015-C
F-0001 CRUDE PASS 3 INLET
SA-JER-DS011-TRJR-480031
FV-0015-D
F-0001 CRUDE PASS 4 INLET
SA-JER-DS011-TRJR-480031
FV-0015-E
F-0001 CRUDE PASS 5 INLET
SA-JER-DS011-TRJR-480032
FV-0015-F
F-0001 CRUDE PASS 6 INLET
SA-JER-DS011-TRJR-480032
FV-0015-G
F-0001 CRUDE PASS 7 INLET
SA-JER-DS011-TRJR-480033
FV-0015-H
F-0001 CRUDE PASS 8 INLET
SA-JER-DS011-TRJR-480033
FV-0021
F-0001 STRIPPING STEAM TO C-0002
SA-JER-DS011-TRJR-480042
TV-0043
DS-0001 BFW
SA-JER-DS011-TRJR-480042
FV-0069
F-0001 FUEL GAS FEED
SA-JER-DS011-TRJR-480115
PV-0136
F-0001 FUEL GAS FEED
SA-JER-DS011-TRJR-480115
FV-0076
F-0001 FUEL GAS FEED
SA-JER-DS011-TRJR-480116
PV-0196
F-0001 FUEL GAS FEED
SA-JER-DS011-TRJR-480116
PV-0395-A
F-0001 STACK DAMPER
SA-JER-DS011-TRJR-480117
PV-0395-B
F-0001 STACK DAMPER
SA-JER-DS011-TRJR-480117
FV-0070
COMBUSTION AIR TO F-0001
SA-JER-DS011-TRJR-480121
FV-0074
COMBUSTION AIR TO F-0001
SA-JER-DS011-TRJR-480121
HV-0015
F-0001/F-0002 DRAFT
SA-JER-DS011-TRJR-480121
PV-0159
K-0003 FLUE GAS SUCTION
SA-JER-DS011-TRJR-480121
TV-0032
E-0040/E-0041 AIR BYPASS
SA-JER-DS011-TRJR-480121
TV-0223
LP STEAM TO E-0041
SA-JER-DS011-TRJR-480121
PV-0160-B
E-0040 AIR DUCT TO F-0001
SA-JER-DS011-TRJR-480269
PV-0160-A
E-0040 AIR DUCT TO F-0001
SA-JER-DS011-TRJR-480269
PV-0160-C
E-0040 AIR DUCT TO F-0001
SA-JER-DS011-TRJR-480269
Table III.2-15: Control Valve of Vacuum Heater Section
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 40 of 244
TAG NUMBER PZV-0009 PZV-0010
SERVICE F-0001 STRIPPING STEAM OUTLET F-0001 STRIPPING STEAM OUTLET
P&ID SA-JER-DS011-TRJR-480042 SA-JER-DS011-TRJR-480042
Table III.2-16: Relief Valves of Crude Heater Section
III.2.5. Crude Distillation
PFD: SA-JER-DS011-TRJR-450002 (Base Case). The partially vaporized crude enters the Atmospheric Column C-0002 at the flash zone. Column total height is 60950 mm and has 57 trays. From tray #1 to #48 column diameter is 7800 mm and from tray #49 to tray #57 diameter is 5400 mm. Bottom internal stripping section diameter is 4800 mm. The feed inlet nozzle is located between trays #6 and #7. It includes a tangential distributor to correctly distribute vapor and adequately de-entrain heaviest components. Atmospheric column operating pressure varies from 1.6 barg (bottom) to 1.0 barg (top), and operating temperature from 354 ºC (bottom) to 119 ºC (top). In addition, the wild naphtha from the LP & HP HDS is processed in the Atmospheric Column. As the quality of these products is similar to a combined cut Naphtha + KERO, the wild naphtha is routed to the LAGO pumparound return line. Alternatively, the wild naptha could be sent to the inlet of Preflash Column C-0001. The crude distillation column is equipped with fractionation sections and pumparound sections with conventional trays to obtain the different crude cuts. These correspond to the following section arrangement, from top to bottom: •
Naphtha / Kerosene fractionation zone
•
Kerosene pumparound zone
•
Kerosene / LAGO fractionation zone
•
LAGO pumparound zone
•
LAGO / HAGO fractionation zone
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 41 of 244
•
HAGO pumparound zone
•
HAGO / FEED fractionation zone
•
Bottom Stripping zone
III.2.5.1. Overhead The overhead vapor leaves the top at 119 ºC and condenses partially through the E0003A-D. Then, it is totally condensed and cooled down in the A-0001A-H to 65ºC and directed to the CDU Reflux Drum D-0004 (at 03 barg and 65ºC). In the D-0004, the water is separated from the naphtha. The produced naphtha is pumped by the CDU Reflux Pumps 011-G-0005 A/B to be mixed with the Naphtha from Preflash Column C-0001 and directed through the E-0021 to the Total Naphtha Drum D-0005. Finally, the naphtha is pumped to the Naphtha Hydrotreating unit (NHDT) by Pumps G-0007 A/B, under flow control FC-0062, reset by the level controller LC-0030. Part of the naphtha flow is sent back as reflux to the column C-0002 under flow control FC-0019. The naphtha cut point is controlled by overhead temperature control TC0101, which reset the reflux flow (FC-0019). The separated water is collected in the D0004 boot. Then, it is directed to the Sour Water Recovery Drum D-0006 by gravity flow under interface level control LDC-0026. Each lateral product cut is sent to a side stripper (C-0004 Kerosene Stripper, C-0005 LAGO Stripper, and C-0006 HAGO Stripper). They are either stripped with superheated LP steam (for LAGO and HAGO) or reboiled (for KERO) to strip out the light ends. The stripping steam is feeding to the LAGO and HAGO Stripper under flow control by FC0027 and FC-0028, respectively. Likewise, striping steam is injected continuously at the bottom of the column C-0002 under flow control by FC-0021. The LP steam is supplied form LPS header and superheated through the convection zone of the Crude Heater F-0001. The liquid level on the C-0004 Kerosene Stripper, C-0005 LAGO Stripper, and C-0006 HAGO Stripper is maintained by LC-0034, LC-0038 and LC-0040, respectively. These controllers act on the valves in the product stream from the column C-0002.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 42 of 244
KERO and LAGO cuts are then sent to LP HDS Unit/ Storage by Kerosene product Pumps G-0009A/B and LAGO Product Pumps G-0011A/B respectively, and HAGO to the HP HDS Unit/ Storage by HAGO Product Pumps G-0013A/B. Because these units have reboiled (KERO) or steam stripping section of the effluents, there is no need to dry KERO, LAGO and HAGO products out of the distillation column before being sent to storage. The KERO, LAGO and HAGO products are under flow control FC-0039, FC0140 and FC-0120 respectively. The column has 3 pumparound (KERO, LAGO and HAGO) allowing to extract heat at several thermal levels for crude preheat trains, and to provide heat for column reboiling in the fractionation section of NHDT (Unit 111), as well as for the Kerosene Stripper. Considering the required duty/temperature level the following heating media are used: •
Naphtha Splitter Reboiler 111-E-0009: LAGO pumparound
•
Naphtha Stripper Reboiler 111-E-0007 & Kerosene Stripper Reboiler 011-E0022: HAGO pumparound
III.2.5.2. Kerosene The Kerosene pumparound (KERO PA) is drawn off at tray #44. Kerosene Pumparound Pump, G-0008 A/B, circulates it through the exchangers E-0007A-D in the crude feed preheat train and returns to tray # 48. The KERO PA flow is maintained under flow control by FC-0003. The level of the KERO draw-off tray is controlled by LC-0010 which acts on flow control FC-0018 in the pumback reflux line of the G-0008A/B. A part of the draw-off is cascaded to the Kerosene Stripper, C-0004 (1.1 barg and 187ºC). This side stripper is equipped with ten two-pass trays and reboiler section to revaporization of light ends increasing the Naphtha recovery rate. Liquid from bottom tray is falling to reboiler sump area, and vapor from E-0022 reboiler return is entering from the opposite side of the C-0004 side stripper. The reboiling duty of C-0004 is controlled thanks to a temperature-flow cascade controller on E-0022. Temperature in the KERO stripper is controlled by TC-0121 acting on FC-0125. The KERO PA system condenses the Kerosene fraction; the duty removal in this section determines the Naphtha/KERO separation. A hot bypass across E-0007A-D is available to control the required KERO PA return temperature through controller TC0024.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 43 of 244
The stripped Kerosene from the C-0004 bottom is pumped by the Kerosene Product Pump G-0009A/B though the heat exchangers E-0008 and E-0001 of the crude preheat train, and cooler E-0023, to reduce the temperature before sending to BL. III.2.5.3. LAGO LAGO pumparound (LAGO PA) is drawn off at tray #30. LAGO Pumparound Pump, G0010 A/B, circulates it through the exchanger E-0013 in the crude feed preheat train and the NHDT Naphtha Splitter Reboiler 111-E-0009 (Unit 111), and returns to the column at tray #34. A part of the draw-off is cascaded to the LAGO Stripper, C-0005 (1.3/1.2 barg and 243/234ºC). This side stripper is equipped with six two-pass trays and steam stripped to enhance the Kerosene recovery rate. The LAGO PA system condenses the LAGO fraction; the duty removal in this section determines the KERO/LAGO separation. A hot bypass across E-0013 is available to control the required LAGO PA return temperature through controller TC-0112. The reboiling duty of Naphtha Splitter, 111-C0002, is controlled thanks to a temperature-flow cascade controller on 11-E-0009. Temperature in the NHDT Splitter is controlled by 111-TC-0109 acting on 111-FV-0028. LAGO PA control loop in Unit 111 is always in operative conditions and 111-E-0009 is used during normal operation as it is designed to give the duty required for the 100% capacity (12.5 Gcal/h). The LAGO PA flow rate going to the NHDT Naphtha Splitter Reboiler should be maintained at around of 385 t/h by adjusting the set point of flow controller 111-FC0028 and the bypass flow through PDV-0385 that bypass circulation through 111-E0009 is 316 t/h. The total LAGO PA flow rate is maintained under flow control by FC0023. The level of the LAGO draw-off tray is controlled by LC-0013 which acts on flow control FC-0024 in the pumback reflux line of the G-0010A/B. The stripped LAGO from the C-0005 bottom is pumped by the LAGO Product Pump G0011A/B though the heat exchangers E-0011A/B, E-0006 and E-0024 of the crude preheat train and coolers A-0003A/B and E-0034, in order to reduce the temperature before sending to BL.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 44 of 244
III.2.5.4. HAGO HAGO pumparound (HAGO PA) is drawn off at tray #15. HAGO Pumparound Pump, G0012 A/B, circulates it through the NHDT Naphtha Stripper Reboiler 111-E-0007 (Unit 111) and return to CDU/VDU unit going to exchangers: E-0022 (KERO Stripper Reboiler); E-0017 A/B in the crude feed preheat train and finally returns to the column at tray #19. A part of the draw-off is cascaded to the HAGO Stripper, C-0006 (1.3 barg and 305 ºC). During normal operation, the HAGO pumparound flow to the Naphtha Stripper Reboiler 111-E-0007 is made by adjusting the flow controller 111-FC-0021 which is setting at 598 t/h and the bypass flow through PDV-0384 that bypass circulation through 111-E0007 is 67 t/h. The total HAGO PA flow rate is maintained under flow control by FC0013. The level of the HAGO draw-off tray is controlled by LC-0016 which acts on flow control FC-0022 in the pumback reflux line of the G-0012A/B. To avoid interferences between the flow controllers of CDU/VDU unit and NHDT unit in the HAGO pumparound line, it could be required to adjust 111-FC-0021 set point to 598.1 t/h, being the HAGO outlet temperature in this case 287 ºC in order to maintain the same duty. The HAGO PA system condenses the HAGO fraction; the duty removal in this section determines the LAGO/HAGO separation. A hot bypass across E-0017 A/B is available to control the required HAGO PA return temperature through controller TC-0079. The stripped HAGO from the C-0006 bottom is pumped by the HAGO Product Pump G0013A/B though the heat exchangers E-0012A/B, E-0009A/B and E-0002 of the crude preheat train and coolers A-0004 and E-0035, in order to reduce the temperature before sending to BL. III.2.5.5. Atmospheric Residue The Atmospheric residue is collected in the bottom of the C-0002. Then, it is pumped by the Atmospheric Residue Pumps G-0014 A/B to the Vacuum Heater F-0002. The bottom liquid level is controlled by LC-0020, which resets the vacuum heater flow master controller FC-0033A/B. These control the total flow of all the passes through the heater. To protect the pumps in the event of very low flow rate, an independent flow
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 45 of 244
controller FC-0032 opens the recirculation valve FV-0032 for returning the Atmospheric Residue to the column. An external overflash draw-off is implemented to measure the overflash flow rate. With this measurement it is possible to verify the fractionation between HAGO and Atmospheric Residue. Reference P&IDs SA-JER-DS011-TRJR-480043 through 480047 SA-JER-DS011-TRJR-480052 through 480066
TAG NUMBER
SERVICE
FC-0018
C-0002 KERO REFLUX
FC-0019
C-0002 NAPHTHA REFLUX
FC-0023
C-0002 LAGO PA RETURN
LC-0010 TC-0101
C-0002 ATMOSPHERIC COLUMN TRAY 44 C-0002 NAPHTHA TOP OUTLET
FC-0022
C-0002 HAGO REFLUX
FC-0024
C-0002 LAGO REFLUX
LC-0013 LC-0016 LC-0020
C-0002 ATMOSPHERIC COLUMN TRAY 30 C-0002 ATMOSPHERIC COLUMN TRAY 15 C-0002 ATMOSPHERIC COLUMN BOTTOM
AC-0019
D-0004 SOUR WATER pH
LC-0024
D-0004 CDU REFLUX DRUM
LDC-0026
D-0004 INTERFACE BOOT
PC-0033
D-0004 CDU REFLUX DRUM
FC-0025
G-0005-A/B NAPHTHA DISCHARGE
FC-0125
E-0022 HAGO PA INLET
LC-0034
C-0004 KERO STRIPPER
PDC-0046
E-0022 HAGO PA BYPASS
TC-0121
E-0022 KERO OUTLET
P&ID SA-JER-DS011-TRJR480043 SA-JER-DS011-TRJR480043 SA-JER-DS011-TRJR480043 SA-JER-DS011-TRJR480043 SA-JER-DS011-TRJR480043 SA-JER-DS011-TRJR480044 SA-JER-DS011-TRJR480044 SA-JER-DS011-TRJR480044 SA-JER-DS011-TRJR480044 SA-JER-DS011-TRJR480044 SA-JER-DS011-TRJR480046 SA-JER-DS011-TRJR480046 SA-JER-DS011-TRJR480046 SA-JER-DS011-TRJR480046 SA-JER-DS011-TRJR480047 SA-JER-DS011-TRJR480052 SA-JER-DS011-TRJR480052 SA-JER-DS011-TRJR480052 SA-JER-DS011-TRJR-
UNITS
SET POINT
t/h
133.4
t/h
97.2
t/h
700.8
%
50
ºC
119
t/h
228.8
t/h
194.7
%
50
%
50
%
50 6
%
83
%
60
barg
0.3
t/h
74.4
t/h
214.6
%
50
bar
1.0
ºC
214
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 46 of 244
TAG NUMBER
SERVICE
FC-0027
C-0005 STRIPPING STEAM
LC-0038
C-0005 LAGO STPR
FC-0028
C-0006 STRIPPING STEAM
LC-0040
C-0006 HAGO STPR
FC-0029
E-0023 KERO OUTLET TO STORAGE
FC-0118
KERO TO LP HDS
FC-0030
E-0034 LAGO OUTLET TO STORAGE
FC-0119
LAGO TO LP HDS
FC-0140
E-0034 LAGO OUTLET
FC-0120
E-0035 HAGO OUTLET
FC-0032-A HC-0020 PC-0446 PDC-0384 PDC-0385
G-0014-A/B C-0002 ATM RES REC VAC RESIDUE FROM 011-G0018-A/B HAGO+LVGO TO BL HAGO PA FROM/TO NHDT UNIT 111 LAGO PA FROM/TO NHDT UNIT 111
P&ID 480052 SA-JER-DS011-TRJR480054 SA-JER-DS011-TRJR480054 SA-JER-DS011-TRJR480056 SA-JER-DS011-TRJR480056 SA-JER-DS011-TRJR480058 SA-JER-DS011-TRJR480058 SA-JER-DS011-TRJR480060 SA-JER-DS011-TRJR480060 SA-JER-DS011-TRJR480060 SA-JER-DS011-TRJR480062 SA-JER-DS011-TRJR480066 SA-JER-DS011-TRJR480066 SA-JER-DS011-TRJR480132 SA-JER-DS011-TRJR480134 SA-JER-DS011-TRJR480140
UNITS
SET POINT
t/h
2.4
%
50
t/h
2.2
%
50
t/h
13.4
t/h
120.1
t/h
12
t/h
108.3
t/h
120.3
t/h
108.9
t/h
240
t/h
559.7
barg
7.0
bar
2.3
bar
2.5
Table III.2-17: Controllers of Crude Distillation Section
TAG NUMBER LT-0010
LT-0012 PT-0029-A PT-0029-B PT-0029-C TT-0245 LT-0013
SERVICE C-0002 ATMOSPHERIC COLUMN TRAY 44 C-0002 ATMOSPHERIC COLUMN TRAY 44 C-0002 NAPHTHA TOP OUTLET C-0002 NAPHTHA TOP OUTLET C-0002 NAPHTHA TOP OUTLET C-0002 NAPHTHA TOP OUTLET C-0002 ATMOSPHERIC COLUMN TRAY 30
P&ID
UNITS
SA-JER-DS011TRJR-480043
%
SA-JER-DS011TRJR-480043
%
5.5
barg
SA-JER-DS011TRJR-480043 SA-JER-DS011TRJR-480043 SA-JER-DS011TRJR-480043 SA-JER-DS011TRJR-480043 SA-JER-DS011TRJR-480044
LL
L
H
26.5
70
0.6
0.8
1.6
2.1
barg
0.6
0.8
1.6
2.1
barg
0.6
0.8
1.6
2.1
ºC %
142 28.8
87.5
HH
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 47 of 244
TAG NUMBER LT-0015
LT-0016
LT-0018
LT-0020
LT-0021 FT-0114 LT-0022 LT-0024 TT-0120 TT-0363 TT-0366
SERVICE C-0002 ATMOSPHERIC COLUMN TRAY 30 C-0002 ATMOSPHERIC COLUMN TRAY 15 C-0002 ATMOSPHERIC COLUMN TRAY 15 C-0002 ATMOSPHERIC COLUMN BOTTOM C-0002 ATMOSPHERIC COLUMN BOTTOM D-0004 VAPOR TO FLARE D-0004 CDU REFLUX DRUM D-0004 CDU REFLUX DRUM C-0004 KERO TO C0002 C-0005 STRIPPING STEAM C-0006 STRIPPING STEAM
TT-0130
E-0023 KERO OUTLET
TT-0323
E-0034 LAGO OUTLET
TT-0325 FT-0032-B PDT-0035 PDT-0065 PT-0427
E-0035 HAGO OUTLET G-0014-A/B ATM RESIDUE RECIRCULATION G-0014A SUCTION STRAINER G-0014B SUCTION STRAINER HAGO PA FROM NHDT UNIT 111
P&ID
UNITS
LL
SA-JER-DS011TRJR-480044
%
5.63
SA-JER-DS011TRJR-480044
%
SA-JER-DS011TRJR-480044
%
SA-JER-DS011TRJR-480044
%
SA-JER-DS011TRJR-480044
%
SA-JER-DS011TRJR-480046 SA-JER-DS011TRJR-480046 SA-JER-DS011TRJR-480046 SA-JER-DS011TRJR-480052 SA-JER-DS011TRJR-480054 SA-JER-DS011TRJR-480056 SA-JER-DS011TRJR-480058 SA-JER-DS011TRJR-480060 SA-JER-DS011TRJR-480062 SA-JER-DS011TRJR-480066 SA-JER-DS011TRJR-480066 SA-JER-DS011TRJR-480066 SA-JER-DS011TRJR-480134
L
H
28.5
86.8
20
80
5.3
5
95
t/h %
HH
5.4 5
%
72.5
ºC
92.5 200
ºC
345
ºC
345
ºC
48
ºC
55
ºC
55
t/h
239.4
mbar
100
mbar
100 9.8
Table III.2-18: Alarms of Crude Distillation Section
TAG NUMBER
SERVICE
P&ID
FV-0018
C-0002 KERO REFLUX
SA-JER-DS011-TRJR-480043
FV-0019
C-0002 NAPHTHA REFLUX
SA-JER-DS011-TRJR-480043
FV-0023
C-0002 LAGO PA RETURN
SA-JER-DS011-TRJR-480043
FV-0022
C-0002 HAGO REFLUX
SA-JER-DS011-TRJR-480044
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 48 of 244
TAG NUMBER
SERVICE
P&ID
FV-0024
C-0002 LAGO REFLUX
SA-JER-DS011-TRJR-480044
LDV-0026
D-0004 INTERFACE BOOT
SA-JER-DS011-TRJR-480046
PV-0033-A
D-0004 BLANKETING
SA-JER-DS011-TRJR-480046
PV-0033-B
SA-JER-DS011-TRJR-480046
FV-0125
D-0004 VENT G-0005-A/B NAP DISCHARGE TO E-0021 E-0022 HAGO PA INLET
SA-JER-DS011-TRJR-480052
LV-0034
C-0004 KERO STRIPPER
SA-JER-DS011-TRJR-480052
PDV-0046
E-0022 HAGO PA BYPASS
SA-JER-DS011-TRJR-480052
FV-0027
C-0005 STRIPPING STEAM
SA-JER-DS011-TRJR-480054
LV-0038
C-0005 LAGO STRIPPER
SA-JER-DS011-TRJR-480054
FV-0028
C-0006 STRIPPING STEAM
SA-JER-DS011-TRJR-480056
LV-0040
C-0006 HAGO STRIPPER E-0023 KERO OUTLET TO STORAGE KERO TO LP HDS E-0034 LAGO OUTLET TO STORAGE LAGO TO LP HDS
SA-JER-DS011-TRJR-480056
FV-0025
FV-0029 FV-0118 FV-0030 FV-0119 FV-0120 FV-0032 HV-0020 PV-0446-A PV-0446-B PDV-0384 PDV-0385
E-0035 HAGO OUTLET G-0014A/B ATM RESIDUE RECIRCULATION VAC RESIDUE FROM G0018A/B HAGO+LVGO TO BL HAGO+LVGO TO STORAGE HAGO PA FROM/TO NHDT UNIT 111 LAGO PA FROM/TO NHDT UNIT 111
SA-JER-DS011-TRJR-480047
SA-JER-DS011-TRJR-480058 SA-JER-DS011-TRJR-480058 SA-JER-DS011-TRJR-480060 SA-JER-DS011-TRJR-480060 SA-JER-DS011-TRJR-480062 SA-JER-DS011-TRJR-480066 SA-JER-DS011-TRJR-480066 SA-JER-DS011-TRJR-480132 SA-JER-DS011-TRJR-480132 SA-JER-DS011-TRJR-480134 SA-JER-DS011-TRJR-480140
Table III.2-19: Control Valve of Crude Distillation Section
TAG NUMBER PZV-0046-A PZV-0046-B PZV-0046-C PZV-0046-D PZV-0046-E
SERVICE C-0002 ATMOSPHERIC COLUMN C-0002 ATMOSPHERIC COLUMN C-0002 ATMOSPHERIC COLUMN C-0002 ATMOSPHERIC COLUMN C-0002 ATMOSPHERIC COLUMN
P&ID SA-JER-DS011-TRJR-480043 SA-JER-DS011-TRJR-480043 SA-JER-DS011-TRJR-480043 SA-JER-DS011-TRJR-480043 SA-JER-DS011-TRJR-480043
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 49 of 244
TAG NUMBER
PZV-0011-A
SERVICE C-0002 ATMOSPHERIC COLUMN C-0002 ATMOSPHERIC COLUMN C-0002 ATMOSPHERIC COLUMN D-0004 CDU REFLUX DRUM
SA-JER-DS011-TRJR-480046
PZV-0011-B
D-0004 CDU REFLUX DRUM
SA-JER-DS011-TRJR-480046
PZV-0012
D-0004 CDU REFLUX DRUM
SA-JER-DS011-TRJR-480046
TZV-0002
E-0023 CWR TUBE SIDE
SA-JER-DS011-TRJR-480058
PZV-0046-F PZV-0046-G PZV-0047
P&ID SA-JER-DS011-TRJR-480043 SA-JER-DS011-TRJR-480043 SA-JER-DS011-TRJR-480043
TZV-0011
E-0034 CWR TUBE SIDE
SA-JER-DS011-TRJR-480060
PZV-0068-A
E-0035 HAGO SHELL SIDE
SA-JER-DS011-TRJR-480062
PZV-0068-B
E-0035 HAGO SHELL SIDE
SA-JER-DS011-TRJR-480062
TZV-0012
E-0035 CWR TUBE SIDE
SA-JER-DS011-TRJR-480062
Table III.2-20: Relief Valves of Crude Distillation Section
III.2.6. Vacuum Heater
PFD: SA-JER-DS011-TRJR-450003 (Base Case). The atmospheric residue from the CDU enters into the Vacuum Heater F-0002 where is partially vaporized to 30%wt and heated to 407 ºC in order to meet the Vacuum Column C-0003 flash zone conditions. The F-0002 consists of two radiant cells with a combined overhead convection section above the arch. The heater is equipped with 16 hearth burners in total, 8 burners in line per cell. Each radiant chamber has eight forced draft burners. Low NOx burners are used. The heater is fired with fuel gas and is designed in order to reach a minimum fuel efficiency of 92%. No steam/air decoking system is required, only pigging facilities are provided. Besides the normal refinery fuel gas, also low pressure off gas proceeding from the Amine Absorber Column (C-0007) is burned in the heater providing about 15% of its liberation.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 50 of 244
The entering atmospheric residue is routed to two cells and divided into eight passes (four passes per cell). For each pass dilution steam is injected into the feed which initiates vaporization under flow control FC-0036 A-H. Flow control on each pass, FC0034 A-H, is designed to maintain a variable distribution of mass flow into each pass with three objectives: achieve an overall fired heater flow set point, achieve equal pass outlet temperature and control the ratio of the steam flow to atmospheric residue flow per pass. The software signal from each FC (dedicated to each pass) is sent in case of passes from A to D to one summing devices and for passes E to H to another summing device to totalize and average the total flow. The two generated total average flow software signal (FC-0033A/FC-0033B) are reset by the level controller signal of the Crude Column (LC-0020) and is shared to be sent back to each pass flow controller. A hand switch button HS-0005 is foreseen to divert the LC-0020 signal to reset the Vacuum residue to storage flow controller (FC-0053) in case of VDU shutdown. At the heater outlet the four passes are routed as individual branches to the transfer line. The average temperature of the four process outlets of each cell is controlled by temperature controllers (TC-0140AA/TC-0140BA) which set the set point of the demand controller FC-0080/FC-0084 for cell A and cell B respectively and the air /fuel ratio system control. In order to prevent the fuel gas pressure lower than the safety level, the signal from heat demand controller FC-0080/0084 is overridden by the minimum pressure controller PC-0213B/0230B via the high selector PY-0213/0230 which manipulate the control valve FV-0080/0084. During start-up operation, the fuel gas pressure is controlled by PC-0213A/0230A which manipulates the smaller control valve PV-0213/0230 for cell A and cell B respectively. A correct air/fuel ratio (or excess O2) is essential for energy efficient operation. In the vacuum heater, the O2 concentration is measured in 2 locations at the arch of each radiation cell. O2 measured value for cell A and cell B fed into the respective O2 controller by AC-0006 and AC-0007. The safe and economic excess O2 concentration can be controlled thru setting an air/fuel ratio correction parameter. A low air/fuel ratio alarm will alert the operator to correct in order to avoid sub-stoichiometric firing. Furthermore, the low-low air/fuel ratio will activate the min firing trip on the heater. The air flow controller FC-0075/0077 is the main tool to control the desired air/fuel ratio. Heat demand controllers 011-FC-0080/0084 manipulate the FV’s. To prevent the main fuel pressure dropping below the min. pressure, one PC min controller per cell PC0213B/0230B will override the heat demand controller output in case the pressure is low than the set point.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 51 of 244
The top of the convection section, above the feed preheat coil, is used to superheat the Low Pressure Steam (partly produced in the Steam Drum D-0011), which is used as stripping steam in the Vacuum Column, C-0003. A desuperheater DS-0002 has been provided to maintain stripping steam temperature from F-0002 to column C-0003 at 350 ºC. The temperature downstream of the desuperheater is controlled by action of the controller TC-0049 which acting on BFW control valve TV-0049. Steam Drum D-0011 is fed with Boiler Feed Water coming from battery limit under level control LC-0065. Stripping steam is partially generated by means of natural circulation through the E-0031A/B (steam generator). Pressure in the D-0011 is controlled by PC0094 acting on control valves PV-0049A and PV-0049B in a split range strategy. LP steam is injected into the steam line to the heater under pressure control PC-0332. To control the BFW quality, a small flow of water is purged continuously and flashed in the Blowdown Drum, D-0013 (0.3 and 107ºC). The condensate is cooled by service water and discharged to the oily water sewer. A conditioning chemical is added to the BFW by the Phosphate Injection Package X-0006. The damper PV-0408 in the duct is used to control a slight negative arch pressure by PC-0408, regulating the pass of the flue gases. The flue gases from the convection section of F-0002 are conducted to the stack base of the Crude Heater, F-0001. Refer to section III.2.4. Reference P&IDs SA-JER-DS011-TRJR-480067 through 480079 SA-JER-DS011-TRJR- 480105 SA-JER-DS011-TRJR-480118 through 480120 SA-JER-DS011-TRJR-480121
TAG NUMBER FC-0034-A FC-0034-B FC-0036-A FC-0036-B FC-0034-C
SERVICE
P&ID
F-0002 ATM RESIDUE PASS 1 INLET F-0002 ATM RESIDUE PASS 2 INLET F-0002 DILUTION STEAM PASS 1 INLET F-0002 DILUTION STEAM PASS 2 INLET F-0002 ATM RESIDUE PASS 3 INLET
SA-JER-DS011-TRJR480067 SA-JER-DS011-TRJR480067 SA-JER-DS011-TRJR480067 SA-JER-DS011-TRJR480067 SA-JER-DS011-TRJR480068
UNITS
SET POINT
t/h
84
t/h
84
t/h
1.1
t/h
1.1
t/h
84
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 52 of 244
TAG NUMBER FC-0034-D FC-0036-C FC-0036-D FC-0034-E FC-0034-F FC-0036-E FC-0036-F FC-0034-G FC-0034-H FC-0036-G FC-0036-H TC-0140-AA TC-0140-A TC-0140-B TC-0140-C TC-0140-D TC-0140-BA TC-0140-E TC-0140-F TC-0140-G TC-0140-H TC-0049
SERVICE
P&ID
F-0002 ATM RESIDUE PASS 4 INLET F-0002 DILUTION STEAM PASS 3 INLET F-0002 DILUTION STEAM PASS 4 INLET F-0002 ATM RESIDUE PASS 5 INLET F-0002 ATM RESIDUE PASS 6 INLET F-0002 DILUTION STEAM PASS 5 INLET F-0002 DILUTION STEAM PASS 6 INLET F-0002 ATM RESIDUE PASS 7 INLET F-0002 ATM RESIDUE PASS 8 INLET F-0002 DILUTION STEAM PASS 7 INLET F-0002 DILUTION STEAM PASS 8 INLET F-0002 OUTLET CELL WEST F-0002 ATM RESIDUE PASS 1 OUTLET F-0002 ATM RESIDUE PASS 2 OUTLET F-0002 ATM RESIDUE PASS 3 OUTLET F-0002 ATM RESIDUE PASS 4 OUTLET F-0002 OUTLET CELL EAST F-0002 ATM RESIDUE PASS 5 OUTLET F-0002 ATM RESIDUE PASS 6 OUTLET F-0002 ATM RESIDUE PASS 7 OUTLET F-0002 ATM RESIDUE PASS 8 OUTLET DS-0002 STRIPPING STEAM
SA-JER-DS011-TRJR480068 SA-JER-DS011-TRJR480068 SA-JER-DS011-TRJR480068 SA-JER-DS011-TRJR480069 SA-JER-DS011-TRJR480069 SA-JER-DS011-TRJR480069 SA-JER-DS011-TRJR480069 SA-JER-DS011-TRJR480070 SA-JER-DS011-TRJR480070 SA-JER-DS011-TRJR480070 SA-JER-DS011-TRJR480070 SA-JER-DS011-TRJR480071 SA-JER-DS011-TRJR480071 SA-JER-DS011-TRJR480072 SA-JER-DS011-TRJR480073 SA-JER-DS011-TRJR480074 SA-JER-DS011-TRJR480075 SA-JER-DS011-TRJR480075 SA-JER-DS011-TRJR480076 SA-JER-DS011-TRJR480077 SA-JER-DS011-TRJR480078 SA-JER-DS011-TRJR480079 SA-JER-DS011-TRJR480118 SA-JER-DS011-TRJR480118 SA-JER-DS011-TRJR480118 SA-JER-DS011-TRJR480119
FC-0080
F-0002 FUEL GAS FEED
PC-0213-A
F-0002 FUEL GAS FEED
PC-0213-B
F-0002 FUEL GAS FEED
FC-0084
F-0002 FUEL GAS FEED
UNITS
SET POINT
t/h
84
t/h
1.1
t/h
1.1
t/h
84
t/h
84
t/h
1.1
t/h
1.1
t/h
84
t/h
84
t/h
1.1
t/h
1.1
ºC
407
ºC
407
ºC
407
ºC
407
ºC
407
ºC
407
ºC
407
ºC
407
ºC
407
ºC
407
ºC
350
barg
1.802
barg
0.05
barg
2.3
barg
1.802
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 53 of 244
TAG NUMBER
SERVICE
PC-0230-A
F-0002 FUEL GAS FEED
PC-0230-B
F-0002 FUEL GAS FEED
AC-0006
F-0002 FLUE GAS O2%
AC-0007
F-0002 FLUE GAS O2%
PC-0408 FC-0075 FC-0077
UNITS
SET POINT
barg
0.05
barg
2.3
%
3
%
3
mmH2O
-2.5
P&ID
F-0002 VACUUM HEATER STACK COMBUSTION AIR TO F0002 COMBUSTION AIR TO F0002
LC-0065
D-0011 STEAM DRUM
PC-0094
D-0011 STEAM DRUM
PC-0332
F-0002 LPS SUPPLY
SA-JER-DS011-TRJR480119 SA-JER-DS011-TRJR480119 SA-JER-DS011-TRJR480120 SA-JER-DS011-TRJR480120 SA-JER-DS011-TRJR480120 SA-JER-DS011-TRJR480121 SA-JER-DS011-TRJR480121 SA-JER-DS011-TRJR480105 SA-JER-DS011-TRJR480105 SA-JER-DS011-TRJR480105
t/h t/h %
50
barg
2.6
barg
2.3
Table III.2-21: Controllers of Vacuum Heater Section
TAG NUMBER FT-0034-AA FT-0034-AB FT-0034-AC FT-0034-BA FT-0034-BB FT-0034-BC FT-0037-A FT-0037-B FT-0034-CA FT-0034-CB FT-0034-CC FT-0034-DA FT-0034-DB
SERVICE
P&ID
F-0002 ATM RESIDUE PASS 1 INLET F-0002 ATM RESIDUE PASS 1 INLET F-0002 ATM RESIDUE PASS 1 INLET F-0002 ATM RESIDUE PASS 2 INLET F-0002 ATM RESIDUE PASS 2 INLET F-0002 ATM RESIDUE PASS 2 INLET F-0002 DILUTION STEAM PASS 1 INLET F-0002 DILUTION STEAM PASS 2 INLET F-0002 ATM RESIDUE PASS 3 INLET F-0002 ATM RESIDUE PASS 3 INLET F-0002 ATM RESIDUE PASS 3 INLET F-0002 ATM RESIDUE PASS 4 INLET F-0002 ATM RESIDUE PASS 4 INLET
SA-JER-DS011TRJR-480067 SA-JER-DS011TRJR-480067 SA-JER-DS011TRJR-480067 SA-JER-DS011TRJR-480067 SA-JER-DS011TRJR-480067 SA-JER-DS011TRJR-480067 SA-JER-DS011TRJR-480067 SA-JER-DS011TRJR-480067 SA-JER-DS011TRJR-480068 SA-JER-DS011TRJR-480068 SA-JER-DS011TRJR-480068 SA-JER-DS011TRJR-480068 SA-JER-DS011TRJR-480068
UNITS
LL
L
t/h
47.51
50.33
t/h
47.51
50.33
t/h
47.51
50.33
t/h
47.51
50.33
t/h
47.51
50.33
t/h
47.51
50.33
t/h
660
t/h
660
t/h
47.51
50.33
t/h
47.51
50.33
t/h
47.51
50.33
t/h
47.51
50.33
t/h
47.51
50.33
H
HH
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 54 of 244
TAG NUMBER FT-0034-DC FT-0037-C FT-0037-D FT-0034-EA FT-0034-EB FT-0034-EC FT-0034-FA FT-0034-FB FT-0034-FC FT-0037-E FT-0037-F FT-0034-GA FT-0034-GB FT-0034-GC FT-0034-HA FT-0034-HB FT-0034-HC FT-0037-G FT-0037-H TT-0140-A TT-0148-A TT-0140-B TT-0148-B TT-0140-C TT-0148-C TT-0140-D
SERVICE
P&ID
F-0002 ATM RESIDUE PASS 4 INLET F-0002 DILUTION STEAM PASS 3 INLET F-0002 DILUTION STEAM PASS 4 INLET F-0002 ATM RESIDUE PASS 5 INLET F-0002 ATM RESIDUE PASS 5 INLET F-0002 ATM RESIDUE PASS 5 INLET F-0002 ATM RESIDUE PASS 6 INLET F-0002 ATM RESIDUE PASS 6 INLET F-0002 ATM RESIDUE PASS 6 INLET F-0002 DILUTION STEAM PASS 5 INLET F-0002 DILUTION STEAM PASS 6 INLET F-0002 ATM RESIDUE PASS 7 INLET F-0002 ATM RESIDUE PASS 7 INLET F-0002 ATM RESIDUE PASS 7 INLET F-0002 ATM RESIDUE PASS 8 INLET F-0002 ATM RESIDUE PASS 8 INLET F-0002 ATM RESIDUE PASS 8 INLET F-0002 DILUTION STEAM PASS 7 INLET F-0002 DILUTION STEAM PASS 8 INLET F-0002 ATM RESIDUE PASS 1 OUTLET F-0002 ATM RESIDUE PASS 1 OUTLET F-0002 ATM RESIDUE PASS 2 OUTLET F-0002 ATM RESIDUE PASS 2 OUTLET F-0002 ATM RESIDUE PASS 3 OUTLET F-0002 ATM RESIDUE PASS 3 OUTLET F-0002 ATM RESIDUE PASS 4 OUTLET
SA-JER-DS011TRJR-480068 SA-JER-DS011TRJR-480068 SA-JER-DS011TRJR-480068 SA-JER-DS011TRJR-480069 SA-JER-DS011TRJR-480069 SA-JER-DS011TRJR-480069 SA-JER-DS011TRJR-480069 SA-JER-DS011TRJR-480069 SA-JER-DS011TRJR-480069 SA-JER-DS011TRJR-480069 SA-JER-DS011TRJR-480069 SA-JER-DS011TRJR-480070 SA-JER-DS011TRJR-480070 SA-JER-DS011TRJR-480070 SA-JER-DS011TRJR-480070 SA-JER-DS011TRJR-480070 SA-JER-DS011TRJR-480070 SA-JER-DS011TRJR-480070 SA-JER-DS011TRJR-480070 SA-JER-DS011TRJR-480071 SA-JER-DS011TRJR-480071 SA-JER-DS011TRJR-480072 SA-JER-DS011TRJR-480072 SA-JER-DS011TRJR-480073 SA-JER-DS011TRJR-480073 SA-JER-DS011TRJR-480074
UNITS
LL
L
t/h
47.51
50.33
t/h
660
t/h
660
t/h
47.51
50.33
t/h
47.51
50.33
t/h
47.51
50.33
t/h
47.51
50.33
t/h
47.51
50.33
t/h
47.51
50.33
t/h
660
t/h
660
t/h
47.51
50.33
t/h
47.51
50.33
t/h
47.51
50.33
t/h
47.51
50.33
t/h
47.51
50.33
t/h
47.51
50.33
t/h
660
t/h
660
ºC
H
412
ºC ºC
430 412
ºC ºC
430 412
ºC ºC
HH
430 412
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 55 of 244
TAG NUMBER TT-0148-D TT-0140-E TT-0148-E TT-0140-F TT-0148-F TT-0140-G TT-0148-G TT-0140-H TT-0148-H TT-0049 TT-0447 PT-0207 PT-0210 PT-0212 PT-0213 PDT-0215 PDT-0216 PT-0219 PDT-0223 PT-0400 PT-0410 PT-0225 PT-0226 PT-0229 PT-0230 PDT-0237
SERVICE
P&ID
F-0002 ATM RESIDUE PASS 4 OUTLET F-0002 ATM RESIDUE PASS 5 OUTLET F-0002 ATM RESIDUE PASS 5 OUTLET F-0002 ATM RESIDUE PASS 6 OUTLET F-0002 ATM RESIDUE PASS 6 OUTLET F-0002 ATM RESIDUE PASS 7 OUTLET F-0002 ATM RESIDUE PASS 7 OUTLET F-0002 ATM RESIDUE PASS 8 OUTLET F-0002 ATM RESIDUE PASS 8 OUTLET DS-0002 STRIPPING STEAM F-0002 STRIPPING STEAM OUTLET F-0002 VENT GAS FEED F-0002 PILOT GAS FEED F-0002 FUEL GAS FEED F-0002 FUEL GAS FEED F-0002 PILOT GAS FEED F-0002 FUEL GAS FEED F-0002 PILOT GAS FEED F-0002 VENT GAS FEED F-0002 PILOT GAS FEED F-0002 FUEL GAS FEED F-0002 PILOT GAS FEED F-0002 PILOT GAS FEED F-0002 FUEL GAS FEED F-0002 FUEL GAS FEED F-0002 VENT GAS FEED
SA-JER-DS011TRJR-480074 SA-JER-DS011TRJR-480075 SA-JER-DS011TRJR-480075 SA-JER-DS011TRJR-480076 SA-JER-DS011TRJR-480076 SA-JER-DS011TRJR-480077 SA-JER-DS011TRJR-480077 SA-JER-DS011TRJR-480078 SA-JER-DS011TRJR-480078 SA-JER-DS011TRJR-480079 SA-JER-DS011TRJR-480079 SA-JER-DS011TRJR-480118 SA-JER-DS011TRJR-480118 SA-JER-DS011TRJR-480118 SA-JER-DS011TRJR-480118 SA-JER-DS011TRJR-480118 SA-JER-DS011TRJR-480118 SA-JER-DS011TRJR-480118 SA-JER-DS011TRJR-480118 SA-JER-DS011TRJR-480118 SA-JER-DS011TRJR-480118 SA-JER-DS011TRJR-480119 SA-JER-DS011TRJR-480119 SA-JER-DS011TRJR-480119 SA-JER-DS011TRJR-480119 SA-JER-DS011TRJR-480119
UNITS
LL
L
H
ºC
430
ºC
412
ºC
430
ºC
412
ºC
430
ºC
412
ºC
430
ºC
412
ºC
430
ºC
340
ºC
360 401
barg
0.1
1.0
barg
0.7
1.1
barg
0.1
barg
4.0 0.15
1.95
bar
0.15
bar
0.15
barg
HH
0.4
1.4
bar
0.05
barg
0.1
4.0
barg
0.05 / 0.2
2.2
barg
0.4
1.4
barg barg barg bar
0.7
1.1
0.1
4.0 0.15
1.95 0.05
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 56 of 244
TAG NUMBER PT-0238 PDT-0242 PDT-0243 PT-0403 PT-0406 PT-0248-A PT-0248-B PT-0248-C PT-0407 PT-0411-A PT-0411-B PT-0411-C FT-0075-A FT-0075-B FT-0075-C FT-0077-A FT-0077-B FT-0077-C
SERVICE
P&ID
F-0002 VENT GAS FEED F-0002 PILOT GAS FEED F-0002 FUEL GAS FEED F-0002 PILOT GAS FEED F-0002 FUEL GAS FEED F-0002 RADIANT HEADER BOX F-0002 RADIANT HEADER BOX F-0002 RADIANT HEADER BOX F-0002 VACUUM HEATER F-0002 RADIANT HEADER BOX F-0002 RADIANT HEADER BOX F-0002 RADIANT HEADER BOX COMBUSTION AIR TO F-0002 COMBUSTION AIR TO F-0002 COMBUSTION AIR TO F-0002 COMBUSTION AIR TO F-0002 COMBUSTION AIR TO F-0002 COMBUSTION AIR TO F-0002
SA-JER-DS011TRJR-480119 SA-JER-DS011TRJR-480119 SA-JER-DS011TRJR-480119 SA-JER-DS011TRJR-480119 SA-JER-DS011TRJR-480119 SA-JER-DS011TRJR-480120 SA-JER-DS011TRJR-480120 SA-JER-DS011TRJR-480120 SA-JER-DS011TRJR-480120 SA-JER-DS011TRJR-480120 SA-JER-DS011TRJR-480120 SA-JER-DS011TRJR-480120 SA-JER-DS011TRJR-480121 SA-JER-DS011TRJR-480121 SA-JER-DS011TRJR-480121 SA-JER-DS011TRJR-480121 SA-JER-DS011TRJR-480121 SA-JER-DS011TRJR-480121 SA-JER-DS011TRJR-480105 SA-JER-DS011TRJR-480105 SA-JER-DS011TRJR-480105 SA-JER-DS011TRJR-480105
LT-0063
D-0011 STEAM DRUM
LT-0065
D-0011 STEAM DRUM BFW FEED
PT-0227
F-0002 LPS FEED
PT-0382
D-0011 STEAM DRUM
UNITS
LL
barg
L
H
0.1
1.0
bar
0.15
bar
0.15
HH
barg
0.1
4.0
barg
0.05 / 0.2
2.2
mmH2O
-10
-1
mmH2O
-10
-1
mmH2O
-10
-1
mmH2O
-10
0
mmH2O
-10
-1
mmH2O
-10
-1
mmH2O
-10
-1
t/h
8.57
12.24
t/h
8.57
12.24
t/h
8.57
12.24
t/h
8.57
12.24
t/h
8.57
12.24
t/h
8.57
12.24
%
87.50
%
17.50 57.50
barg
2.2
barg
3.7
Table III.2-22: Alarms of Vacuum Heater Section
TAG NUMBER
SERVICE
P&ID
FV-0034-A
F-0002 ATM RESIDUE PASS 1 INLET
SA-JER-DS011-TRJR-480067
FV-0034-B
F-0002 ATM RESIDUE
SA-JER-DS011-TRJR-480067
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 57 of 244
TAG NUMBER
SERVICE
P&ID
PASS 2 INLET FV-0036-A FV-0036-B FV-0034-C FV-0034-D FV-0036-C FV-0036-D FV-0034-E FV-0034-F FV-0036-E FV-0036-F FV-0034-G FV-0034-H FV-0036-G FV-0036-H
F-0002 DILUTION STEAM PASS 1 INLET F-0002 DILUTION STEAM PASS 2 INLET F-0002 ATM RESIDUE PASS 3 INLET F-0002 ATM RESIDUE PASS 4 INLET F-0002 DILUTION STEAM PASS 3 INLET F-0002 DILUTION STEAM PASS 4 INLET F-0002 ATM RESIDUE PASS 5 INLET F-0002 ATM RESIDUE PASS 6 INLET F-0002 DILUTION STEAM PASS 5 INLET F-0002 DILUTION STEAM PASS 6 INLET F-0002 ATM RESIDUE PASS 7 INLET F-0002 ATM RESIDUE PASS 8 INLET F-0002 DILUTION STEAM PASS 7 INLET F-0002 DILUTION STEAM PASS 8 INLET
SA-JER-DS011-TRJR-480067 SA-JER-DS011-TRJR-480067 SA-JER-DS011-TRJR-480068 SA-JER-DS011-TRJR-480068 SA-JER-DS011-TRJR-480068 SA-JER-DS011-TRJR-480068 SA-JER-DS011-TRJR-480069 SA-JER-DS011-TRJR-480069 SA-JER-DS011-TRJR-480069 SA-JER-DS011-TRJR-480069 SA-JER-DS011-TRJR-480070 SA-JER-DS011-TRJR-480070 SA-JER-DS011-TRJR-480070 SA-JER-DS011-TRJR-480070
TV-0049
DS-0002 BFW FEED
SA-JER-DS011-TRJR-480079
FV-0080
F-0002 FUEL GAS FEED
SA-JER-DS011-TRJR-480118
PV-0213
F-0002 FUEL GAS FEED
SA-JER-DS011-TRJR-480118
FV-0084
F-0002 FUEL GAS FEED
SA-JER-DS011-TRJR-480119
PV-0230
F-0002 FUEL GAS FEED
SA-JER-DS011-TRJR-480119
PV-0408 FV-0075 FV-0077
F-0002 VACUUM HEATER STACK COMBUSTION AIR TO F0002 COMBUSTION AIR TO F0002
SA-JER-DS011-TRJR-480120 SA-JER-DS011-TRJR-480121 SA-JER-DS011-TRJR-480121
LV-0065
D-0011 BFW FEED
SA-JER-DS011-TRJR-480105
PV-0094-A
D-0011 LPS TO F-0002
SA-JER-DS011-TRJR-480105
PV-0094-B
D-0011 STEAM DRUM VENT
SA-JER-DS011-TRJR-480105
PV-0332
F-0002 LPS SUPPLY
SA-JER-DS011-TRJR-480105
Table III.2-23: Control Valve of Vacuum Heater Section
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 58 of 244
TAG NUMBER PZV-0017 PZV-0018
SERVICE F-0002 STRIPPING STEAM OUTLET F-0002 STRIPPING STEAM OUTLET
P&ID SA-JER-DS011-TRJR-480079 SA-JER-DS011-TRJR-480079
PZV-0028
D-0011 STEAM DRUM
SA-JER-DS011-TRJR-480105
PZV-0029
D-0011 STEAM DRUM
SA-JER-DS011-TRJR-480105
Table III.2-24: Relief Valves of Vacuum Heater Section
III.2.7. Vacuum distillation
PFDs: SA-JER-DS011-TRJR-450003 and SA-JER-DS011-TRJR-450021 (Base Case). The partially vaporized atmospheric residue enters into the Vacuum Column C-0003 at the flash zone. The technology implemented is wet vacuum distillation with injection steam in the heater feed and stripping steam in the column bottom. A pre-condenser is used before a “classic” top vacuum system, with three ejector stages and intercondensers. The column C-0003 is equipped with structured packing between top and the flash zone in order to limit the pressure drop and consequently to maximize vacuum in flash zone. Column total height is 50150 mm. Top section diameter is 7000 mm, central section diameter is 9000 mm, bottom stripping section diameter is 7200 mm and bottom section diameter is 3800 mm. The feed inlet nozzle is a tangential distributor to correctly distribute vapour and adequately de-entrain heaviest components and it is located between trays #6 and #7. Vacuum column operating pressure varies from 127 mmHg abs (bottom) to 85 mmHg abs (top), and operating temperature from 360 ºC (bottom) to 80 ºC (top). The column is configured in order to be able to: •
Withdraw 3 lateral cuts of distillates: LVGO, MVGO and HVGO, and vacuum residue in the bottom. The MVGO and HVGO cuts will be blended in a single cut that will feed the MHC/DHC
•
Limit the metal content in HVGO cut (wash oil section)
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 59 of 244
•
Extract heat from the column
Column internals corresponds to the following section arrangement, from top to bottom: •
LVGO pumparound zone.
•
LVGO/MVGO Fractionation zone
•
HVGO pumparound zone.
•
Washing section
•
Stripping section
III.2.7.1. Overhead The overhead gases are directed to the Vacuum System Package, X-0001, consisting of precondensers E-0025A-D, first stage ejectors J-0001A/B/C, inter-condenser E-0026, second stage ejectors J-0002A/B/C, inter-condenser E-0027, third stage ejectors, J0003 A/B/C and aftercondenser E-0028. The system is designed considering only two ejectors per stage are required for design load (50% design capacity each), so one can be taken out of service for maintenance. Likewise, the design capacity for inter-condensers E-0026, E-0027 and E-0028 are 150% normal capacity. The ejectors compress the gases by “venturi effect” using medium pressure steam (from MPS header) as motive fluid. The steam pressure is controlled by PC-0381 at the common supply line. The vapor exhaust from ejectors is partially condensed in intercondenser with cooling water, and the vapor phase is sent to the next ejector stage. The pressure in the flash zone of Vacuum Column is controlled by the PC-0072, adjusting the spillback valve PV-0072 in the recirculation line from1st Stage Ejectors, J0001A/B/C to Precondenser E-0025A-D inlet. The recirculated vapor flow add load on the precondenser (mainly non-condensables), reducing the suction capacity of the ejectors and therefore increasing the column pressure. The non-condensable gases (or Off Gas), including air and light hydrocarbon produced by cracking in the heater, exits the vacuum system and are directed to the VDU Off Gas
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 60 of 244
Seal Pot D-0009 (0.3 barg and 50ºC). The D-0009 is balanced with Vacuum System Recovery Drum D-0008 via an equilibrium line. Also, the liquid trapped in Seal Pot overflows to the D-0008. The condensates from all condensers drain to Vacuum System Recovery Drum D-0008 (0.3 barg and 50ºC) via barometric legs, where recovered oil and sour water are separated. Recovered oil is pumped by G-0020A/B, and blended with LVGO stream. Recovered oil level in D-0008 is controlled by LC-0057 which resets flow controllers FC0153 and FC-0152 in a split range to distribute to HP HDS unit and storage. Sour water collected in D-0008 is pumped by Vacuum System Sour Water Pump G0019 A/B under level control LC-0060 and injected into the CDU Sour Water Pump G0006 discharge line. Then, the sour water is sent to SWS Unit at BL. III.2.7.2. LVGO The LVGO pumparound and product are drawn off from the top chimney tray. The draw-off liquid is pumped by the LVGO Pumps G-0015A/B back to the column and through the E-0005 and the A-0005A/B. Most of the cooled liquid is returned to the top of the LVGO bed as pumparound reflux. The remaining LVGO product is further cooled in E-0029 and blended with the Recovered Oil (liquid hydrocarbons from the vacuum system). This blend is mixed with the HAGO stream and it is sent to HP HDS Unit/Storage. The overhead column temperature is controlled at 80ºC by TC-0198 resetting the LVGO pumparound flow controller (011-FC-0038). The pumpback reflux is under flow control FC-0046. Total LVGO product flow rate is under level control by LC-0044 in cascade with flow controller FC-0144. HAGO+LVGO sent to HP HDS unit is pressure controlled by PC-0446 adjusting flow rate in the HAGO+LVGO stream to storage in a split range strategy with control valves PV-0446A/B. III.2.7.3. HVGO The HVGO pumparound and product are drawn off from the column and pumped by the HVGO Pumps G-0017A/B back to the column and through the E-0019A-F and E0016A/B. Pumpback reflux is under flow control 011-FC-0051. Most of the cooled liquid is returned to the top of the HVGO bed as pumparound reflux under flow control FC0012.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 61 of 244
The temperature of pumparound is controlled by TC-0069 via bypass line of E-0019A- F and E-0016A/B. The remaining HVGO product is blended with the MVGO. MVGO is drawn off from the upper column section and pumped by the MVGO Pumps G0016A/B. This blend, after being cooled in the crude preheat train consisting of heat exchangers E-0015 A/B and E-0010 A/B, is sent to the MHC/DHC unit and Storage. The MVGO and HVGO streams are under flow control reset by the level controller on the chimney tray of each product, FC-0155A reset by LC-0046 and FC-0049 reset by LC-0048, respectively. HVGO sent to DHC/MHC unit is pressure controlled via PC-0338 by regulating the flow rate in the HVGO stream to storage. A tempered water closed system is used for final rundown cooling of the HVGO through E-0030A/B before sent to storage. HVGO stream to storage is temperature controlled via TC-0173 by regulating the tempered water flow rate (FC-0073A). Tempered water system is a closed loop; the water is pumped by the Tempered Water Pumps G-0022 A/B to the E-0030A/B, to cool down the HVGO stream. Then, the hot tempered water (85ºC) is cooled down in A-0007A-F and returned to the suction of G-0022A/B. The cold water temperature is controlled by TC-0230 split range with the A-0007A-F inlet and bypass valve (TV-0230A/B). The Tempered Water Drum D-0010 (Atm, 65ºC) is an expansion tank for variations of water volume due to temperature changes. The drum is hydraulic balanced with the A0007A-F outlet. The level is controlled by LC-0010 which acts on the control valve in BFW make-up line. III.2.7.4. Vacuum Residue In the stripping section at the column C-0003 bottom, the residue is stripped with superheated low pressure steam at 150ºC.The steam is partially produced in the Steam Drum D-0011 (2.6 barg and 140ºC) and E-0031A/B, and superheated in the convection zone of Vacuum Heater. The stripping steam flow to the column is controlled by means of FC-0056 in the injection line. The normal flow is 17.6 t/h. The stripped vacuum residue product is collected in the bottom of the column C-0003, which has been designed for minimum liquid hold-up time. Then, residue is pumped by Vacuum Residue Pumps G-0018 A/B and cooled down to 205ºC through crude feed preheat train including the heat exchangers: E-0020 A-F, E-0018 A-D, and E-0014 A-F, before being sent to the DCU Unit.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 62 of 244
Provision has been made to recycle part of the cooled vacuum residue (after E-0018AD) as quench stream to the bottom of the vacuum column. The objective is to control the bottom temperature by TC-0204 resetting the quench flow rate (FC-0063) in order to eliminate incipient cracking. The Vacuum Residue product is under flow control to split total flow rate to DCU and storage by FC-0052 and FC-0053 respectively. The total flow is resetted by low signal selector which compares the flow demanded as per level controller LC-0050 against the flow rate demanded in the Coker Unit. The Vacuum Residue to storage is further cooled down through E-0031A/B to reduce temperature until 180ºC. The outlet temperature is controlled by TC-0175 regulating the control valve in the residue bypass of E-0031B. The transferred heat is used to produce low pressure steam for column stripping, as described in section III.2.6. An external overflash draw-off external is implemented to measure the overflash flow rate. With this measurement it is possible to reduce/increase the wash rate in order to improve column performance and minimize the risk of coking. Reference P&IDs SA-JER-DS011-TRJR-480080 through 480089 SA-JER-DS011-TRJR-480096 through 480106 SA-JER-DS011-TRJR-480122 through 480124 SA-JER-DS011-TRJR-480141
TAG NUMBER
SERVICE
FC-0038
LVGO PA FROM A-0005
LC-0044 LC-0046 TC-0198 LC-0048 LC-0050 PC-0072 PC-0381 LC-0057
C-0003 VAC COLUMN LVGO CHIMNEY TRAY C-0003 VAC COLUMN MVGO CHIMNEY TRAY C-0003 OVERHEAD TO E0025 C-0003 VAC COLUMN HVGO CHIMNEY TRAY C-0003 VAC COLUMN BOTTOM C-0003 VAC COLUMN FLASH ZONE D-0024 MPS TO VAC SYSTEM D-0008 VACUUM SYSTEM RECOVERY DRUM
P&ID SA-JER-DS011-TRJR480080 SA-JER-DS011-TRJR480080 SA-JER-DS011-TRJR480080 SA-JER-DS011-TRJR480080 SA-JER-DS011-TRJR480081 SA-JER-DS011-TRJR480081 SA-JER-DS011-TRJR480081 SA-JER-DS011-TRJR480084 SA-JER-DS011-TRJR480086
UNITS
SET POINT
t/h
378.6
%
50
%
50
ºC
80
%
50
%
50
mmHg
103
barg
13.9
%
50
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 63 of 244
TAG NUMBER LC-0060 FC-0152 FC-0153 AC-0017
SERVICE
P&ID
D-0008 VACUUM SYSTEM RECOVERY DRUM G-0020A/B SLOP OIL TO HEADER G-0020A/B SLOP OIL TO STORAGE G-0019A/B SOUR WATER pH
SA-JER-DS011-TRJR480086 SA-JER-DS011-TRJR480087 SA-JER-DS011-TRJR480087 SA-JER-DS011-TRJR480088 SA-JER-DS011-TRJR480096 SA-JER-DS011-TRJR480097 SA-JER-DS011-TRJR480097 SA-JER-DS011-TRJR480097 SA-JER-DS011-TRJR480097 SA-JER-DS011-TRJR480098 SA-JER-DS011-TRJR480099 SA-JER-DS011-TRJR480100 SA-JER-DS011-TRJR480100 SA-JER-DS011-TRJR480102 SA-JER-DS011-TRJR480103 SA-JER-DS011-TRJR480104 SA-JER-DS011-TRJR480104 SA-JER-DS011-TRJR480104 SA-JER-DS011-TRJR480106 SA-JER-DS011-TRJR480141 SA-JER-DS011-TRJR480141 SA-JER-DS011-TRJR480122 SA-JER-DS011-TRJR480123 SA-JER-DS011-TRJR480124
FC-0046
C-0003 LVGO REFLUX
TC-0369-A
A-0005A-D LVGO OUTLET
TC-0369-C
A-0005A-D LVGO OUTLET
TC-0369-E
A-0005A-D LVGO OUTLET
TC-0369-G
A-0005A-D LVGO OUTLET
FC-0144
LVGO TO HP HDS
FC-0155-A
G-0016A/B MVGO PRODUCT
PC-0338
HOT HVGO TO DHC/MHC
TC-0173
COLD HVGO TO STORAGE
FC-0051-A
S-0002 HVGO INLET
TC-0204
VAC RESIDUE TO G0018A/B
FC-0052
VAC RESIDUE TO DCU
FC-0053 TC-0175 FC-0056
VAC RESIDUE TO STORAGE E-0031A/B VAC RESIDUE OUTLET STRIPPING STEAM TO C0003
FC-0012
HVGO PA RETURN
TC-0069
HVGO PA RETURN
LC-0110 TC-0230 FC-0073-A
D-0010 TEMPERED WATER DRUM A-0007A-C TEMPERED WATER OUTLET G-0022A/B DISCHARGE
UNITS
SET POINT
%
60
t/h
0
t/h
6.7
-
6
t/h
93.4
ºC
60
ºC
60
ºC
60
ºC
60
t/h
33.2
t/h
102
barg
13.3
ºC
90
t/h
84.2
ºC
360
t/h
314.6
t/h
34.9
ºC
180
t/h
17.6
t/h
791.9
ºC
267
%
50
ºC
65
t/h
213
Table III.2-25: Controllers of Vacuum Column Section
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 64 of 244
TAG NUMBER LT-0044
LT-0046
LT-0053
LT-0054 PT-0067 PT-0305 TT-0205 LT-0048 LT-0050 LT-0051 LT-0052 LT-0126 PDT-0103 PT-0306 LT-0117 TT-0155 LT-0055
LT-0057
LT-0058
LT-0060 LT-0062
SERVICE C-0003 VAC COLUMN LVGO CHIMNEY TRAY C-0003 VAC COLUMN MVGO CHIMNEY TRAY C-0003 VAC COLUMN MVGO CHIMNEY TRAY C-0003 VAC COLUMN LVGO CHIMNEY TRAY C-0003 VAC COLUMN OVERHEAD C-0003 VAC COLUMN OVERHEAD C-0003 VAC COLUMN OVERHEAD C-0003 VAC COLUMN HVGO CHIMNEY TRAY C-0003 VAC COLUMN BOTTOM C-0003 VAC COLUMN BOTTOM C-0003 VAC COLUMN HVGO CHIMNEY TRAY C-0003 VAC COLUMN BOTTOM C-0003 VAC COLUMN WASH OIL SECTION C-0003 VAC COL FLASH ZONE D-0024 MOTIVE STEAM POT D-0024 MOTIVE STEAM POT OUTLET D-0008 VACUUM SYSTEM RECOVERY DRUM D-0008 VACUUM SYSTEM RECOVERY DRUM D-0008 VACUUM SYSTEM RECOVERY DRUM WATER D-0008 VACUUM SYSTEM RECOVERY DRUM WATER D-0009 VDU OFF GAS SEAL POT
P&ID
UNITS
SA-JER-DS011TRJR-480080
L
H
%
31.88
85.63
SA-JER-DS011TRJR-480080
%
41.43
90
SA-JER-DS011TRJR-480080
%
14.29
SA-JER-DS011TRJR-480080
%
6.25
SA-JER-DS011TRJR-480080 SA-JER-DS011TRJR-480080 SA-JER-DS011TRJR-480080 SA-JER-DS011TRJR-480081 SA-JER-DS011TRJR-480081 SA-JER-DS011TRJR-480081 SA-JER-DS011TRJR-480081 SA-JER-DS011TRJR-480081 SA-JER-DS011TRJR-480081 SA-JER-DS011TRJR-480081 SA-JER-DS011TRJR-480084 SA-JER-DS011TRJR-480084
LL
barg
HH
127
barg
75
98
ºC
75
85
%
31.5
84.5
%
20.23
63.86
%
5.68
%
8
94.32
%
63.86
mmHg
0.6
mmHg
90
%
120 84.17
ºC
245
300
24
86
SA-JER-DS011TRJR-480086
%
SA-JER-DS011TRJR-480086
%
SA-JER-DS011TRJR-480086
%
SA-JER-DS011TRJR-480086
%
34.75
82.75
SA-JER-DS011TRJR-480089
%
69.23
92.31
6.25
8.75
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 65 of 244
TAG NUMBER PT-0083 TT-0168 TT-0039 TT-0349 FT-0155-A FT-0155-B TT-0202 PDT-0106 PDT-0107 FT-0051-B PT-0041 PDT-0091 PDT-0108 PDT-0109 TT-0203 TT-0177 TT-0180 TT-0181 TT-0070 LT-0108 TT-0229 FT-0073-B PDT-0024
SERVICE
P&ID
D-0009 VDU OFF GAS SEAL POT OUTLET A-0005A-D LVGO OUTLET
SA-JER-DS011TRJR-480089 SA-JER-DS011TRJR-480097 SA-JER-DS011TRJR-480098 SA-JER-DS011TRJR-480098 SA-JER-DS011TRJR-480099 SA-JER-DS011TRJR-480099 SA-JER-DS011TRJR-480100 SA-JER-DS011TRJR-480101 SA-JER-DS011TRJR-480101 SA-JER-DS011TRJR-480102 SA-JER-DS011TRJR-480102 SA-JER-DS011TRJR-480102 SA-JER-DS011TRJR-480103 SA-JER-DS011TRJR-480103 SA-JER-DS011TRJR-480103 SA-JER-DS011TRJR-480104 SA-JER-DS011TRJR-480106 SA-JER-DS011TRJR-480106 SA-JER-DS011TRJR-480141 SA-JER-DS011TRJR-480122
LVGO TO HP HDS E-0029 LVGO SHELL SIDE OUTLET G-0016A/B MVGO DISCHARGE G-0016A/B MVGO DISCHARGE COLD HVGO TO STORAGE G-0017A HVGO SUCTION G-0017B HVGO SUCTION S-0002 HVGO INLET S-0002 HVGO OUTLET S-0002 HVGO REFLUX FILTER G-0018A VAC RESIDUE SUCTION G-0018B VAC RESIDUE SUCTION VAC RESIDUE TO G0018A/B VAC RESIDUE TO STORAGE STRIPPING STEAM TO C-0003 STRIPPING STEAM FROM F-0002 S-0001 HVGO PA RETURN D-0010 TEMPERED WATER DRUM A-0007A-D TEMPERED WATER OUTLET G-0022A/B DISCHARGE S-0001 HVGO PA FILTER
SA-JER-DS011TRJR-480123 SA-JER-DS011TRJR-480124 SA-JER-DS011TRJR-480141
UNITS
LL
barg
L
H
0.07
0.8
ºC
66
ºC
55
ºC
55
t/h t/h
40.34 38.56
ºC
85
95
mbar
100
mbar
100
t/h
50.54
101.01
barg
4.0
bar
1.0
mbar
100
mbar
100
ºC
365
ºC
185
ºC ºC
345 155
ºC
273
%
14.7
85.3
ºC
60
70
t/h
95
bar
Table III.2-26: Alarms of Vacuum Distillation Section
1.0
HH
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 66 of 244
TAG NUMBER
SERVICE
P&ID
FV-0038
LVGO PA FROM A-0005
SA-JER-DS011-TRJR-480080
PV-0072
C-0003 TOP SPILL BACK
SA-JER-DS011-TRJR-480084
PV-0381
D-0024 MPS TO VAC SYSTEM
SA-JER-DS011-TRJR-480084
FV-0152
G-0020A/B OIL TO SLOP HEADER
SA-JER-DS011-TRJR-480087
FV-0153
G-0020A/B OIL TO STORAGE
SA-JER-DS011-TRJR-480087
LV-0060
D-0008 VACUUM SYSTEM RECOVERY DRUM
SA-JER-DS011-TRJR-480088
FV-0046
C-0003 LVGO REFLUX
SA-JER-DS011-TRJR-480096
FV-0144
LVGO TO HP HDS
SA-JER-DS011-TRJR-480098
FV-0155
G-0016A/B MVGO PRODUCT
SA-JER-DS011-TRJR-480099
PV-0338
HOT HVGO TO DHC/MHC
SA-JER-DS011-TRJR-480100
TV-0173
COLD HVGO TO STORAGE
SA-JER-DS011-TRJR-480100
FV-0051
S-0002 HVGO INLET
SA-JER-DS011-TRJR-480102
LV-0050
C-0003 VAC COLUMN BOTTOM
SA-JER-DS011-TRJR-480103
FV-0052
VAC RESIDUE TO DCU
SA-JER-DS011-TRJR-480104
FV-0053
VAC RESIDUE TO STORAGE
SA-JER-DS011-TRJR-480104
TV-0175 FV-0056
E-0031-B VAC RESIDUE BYPASS STRIPPING STEAM TO C0003
SA-JER-DS011-TRJR-480104 SA-JER-DS011-TRJR-480106
FV-0046
C-0003 LVGO REFLUX
SA-JER-DS011-TRJR-480096
FV-0012
HVGO PA RETURN
SA-JER-DS011-TRJR-480141
TV-0069
HVGO PA RETURN
SA-JER-DS011-TRJR-480141
LV-0110
D-0010 BFW MAKE-UP
SA-JER-DS011-TRJR-480122
TV-0230-A TV-0230-B FV-0073
A-0007A-C TEMPERED WATER BYPASS A-0007A-C TEMPERED WATER INLET G-0022A/B RECIRCULATION
SA-JER-DS011-TRJR-480123 SA-JER-DS011-TRJR-480123 SA-JER-DS011-TRJR-480124
Table III.2-27: Control Valve of Vacuum Distillation Section
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 67 of 244
TAG NUMBER
SERVICE
P&ID
PZV-0019-A
C-0003 VACUUM COLUMN
SA-JER-DS011-TRJR-480080
PZV-0019-B
C-0003 VACUUM COLUMN
SA-JER-DS011-TRJR-480080
PZV-0019-C
C-0003 VACUUM COLUMN
SA-JER-DS011-TRJR-480080
PZV-0020
C-0003 VACUUM COLUMN
SA-JER-DS011-TRJR-480080
TZV-0003
E-0026/E-0027/E-0028 CWT
SA-JER-DS011-TRJR-480082
TZV-0014
E-0025A-D CWS
SA-JER-DS011-TRJR-480082
PZV-0024 PZV-0025
D-0008 VACUUM SYSTEM RECOVERY DRUM D-0008 VACUUM SYSTEM RECOVERY DRUM
SA-JER-DS011-TRJR-480086 SA-JER-DS011-TRJR-480086
PZV-0086
G-0020A/B DISCHARGE
SA-JER-DS011-TRJR-480087
PZV-0087
G-0020A/B DISCHARGE
SA-JER-DS011-TRJR-480087
PZV-0069-A
E-0029 LVGO SHELL SIDE
SA-JER-DS011-TRJR-480098
PZV-0069-B
E-0029 LVGO SHELL SIDE
SA-JER-DS011-TRJR-480098
TZV-0004
E-0029 CWR TUBE SIDE
SA-JER-DS011-TRJR-480098
TZV-0005 PZV-0070 PZV-0075
E-0030A/B TEMPERED WATER OUTLET S-0002 HVGO REFLUX FILTER S-0001 HVGO PA FILTER
SA-JER-DS011-TRJR-480100 SA-JER-DS011-TRJR-480102 SA-JER-DS011-TRJR-480141
Table III.2-28: Relief Valves of Vacuum Distillation Section
III.2.8. Sour Water
PFDs: SA-JER-DS011-TRJR-450020, SA-JER-DS011-TRJR-450002 and SA-JERDS011-TRJR-450021 (Base Case). The sour process water separated in the Preflash Reflux Drum D-0003, CDU Reflux Drum D-0004 and Total Naphtha Drum D-0005 are sent by gravity flow to Sour Water Recovery Drum D-0006. It operates at 0.3 barg and 62 ºC. The water collected in the D-0006 is directed under level control LC-0080 to Sour Water Stripping Unit (Unit 213) by CDU Sour Water Pumps G-0006 A/B. The sour water from Vacuum System Recovery Drum D-0008 is added at G-0006 A/B discharge line before
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 68 of 244
BL. The stripped water from Unit 213 is returned to CDU/VDU to be used as desalting water. Reference P&IDs SA-JER-DS011-TRJR-480113 through 480114
TAG NUMBER
SERVICE
P&ID
UNITS
SET POINT
LC-0080
D-0006 SOUR WATER RECOVERY DRUM
SA-JER-DS011-TRJR480113
%
60
Table III.2-29: Controllers of Sour Water Section
TAG NUMBER
SERVICE
P&ID
LT-0080
D-0006 SOUR WATER RECOVERY DRUM
LT-0100
011-D-0006 INTERFACE
LT-0107
D-0006 SOUR WATER RECOVERY DRUM
SA-JER-DS011TRJR-480113 SA-JER-DS011TRJR-480113 SA-JER-DS011TRJR-480113
UNITS
LL
L
H
%
36.67 86.19
%
60.63
%
HH
6.67
Table III.2-30: Alarms of Sour Water Section
TAG NUMBER
SERVICE
P&ID
LV-0080
D-0006 SOUR WATER RECOVERY DRUM
SA-JER-DS011-TRJR-480114
Table III.2-31: Control Valve of Sour Water Section
III.2.9. Compressor / Amine Absorber
PFD: SA-JER-DS011-TRJR-450021 (Base Case). The sour gas, coming from vacuum system package X-0001 passes through the Off Gas Compressor KO Drum, D-0016 (50ºC, 0.3barg). The purpose of D-0016 is to separate any liquid condensed from the gas to prevent any damage to the downstream compressor. The liquid collected (mainly water) in the drum is retired by a KO Drum Hydro-ejector J-0004 and send to D-0008. The level in D-0016 is controlled by LC-0097 acting on LV-0097, which regulates the flow of motive fluid (sour water) to the hydroejector.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 69 of 244
From the D-0016, the sour gas enters the VDU Off-Gas Compressor, K-0001, to raise pressure until 2.5 barg. The compressor is a positive displacement (rotary screw) type. In order to ensure a stable operation of the compressor, the suction pressure is controlled by means of PC-0308 acting on control valve PV-0308 in the gas recycle line. This valve, in open position, also functions as an equalising valve when the compressor is not running and during startup and shutdown. After leaving the compressor, the gas is cooled down in the E-0036 from 122ºC to 42ºC and runs into the Amine Absorber KO Drum D-0017 (41ºC, 2.1 barg). This gas/liquid separator removes the condensed water after compression and cooling of the gas. The liquid level is controlled by LC-0070, which opens the LV-0070 in the drain line. The water is sent to the D-0008. The compressed gas leaves the D-0017 from the top and is routed to the Amine Absorber C-0007 (2 barg and 71ºC). This is a trayed column. Amine absorber is fed with lean amine coming from Amine Regeneration Unit (Unit 203) under flow control FC-0067 and washes the sour off gas to remove H2S. The sweetened gas product stream leaves the absorber from the top under pressure control, by PC-0113, and is routed to the Vacuum Heater F-0002 burners as fuel gas. The resultant rich amine is pumped by Rich Amine Pump G-0023 A/B to the Amine Regeneration Unit (Unit 203), under level control LC-0074 of the C-0007 bottom. During an upset operation when K-0001 is shutdown, the untreated off-gas from VDU Off Gas Seal Pot D-0009 will be bypassed and sent directly to flare header through a line connected to the off-gas line to Vacuum Heater F-0002. The alignment of the ZVs valves to bypass the compressor/absorber system is initiated automatically by the compressor interlock. Reference P&IDs SA-JER-DS011-TRJR-480090 through 480095
TAG NUMBER LC-0097 PC-0308 LC-0070 FC-0067-A
SERVICE
P&ID
D-0016 OFF GAS COMPRESSOR KO DRUM D-0016 OFF GAS COMPRESSOR KO DRUM D-0017 AMINE ABSORBER KO DRUM
SA-JER-DS011-TRJR480090 SA-JER-DS011-TRJR480090 SA-JER-DS011-TRJR480093 SA-JER-DS011-TRJR480094
C-0007 LEAN AMINE FEED
UNITS
SET POINT
%
40
Barg
0.3
%
50
t/h
8.0
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 70 of 244
TAG NUMBER
SERVICE
LC-0074
C-0007 AMINE ABSORBER
PC-0113
C-0007 TOP VENT GAS OUTLET
P&ID SA-JER-DS011-TRJR480094 SA-JER-DS011-TRJR480094
UNITS
SET POINT
%
50
bar
2.0
Table III.2-32: Controllers of Compressor/Amine Absorber Section
TAG NUMBER LT-0096
LT-0097 FT-0550-A FT-0550-B
SERVICE D-0016 OFF GAS COMPRESSOR KO DRUM D-0016 OFF GAS COMPRESSOR KO DRUM K-0001 COOLING MEDIA OUT K-0001 COOLING MEDIA OUT
PT-0550
K-0001 INLET
PT-0551-A
K-0001 INLET
PT-0551-B PDT-0552 PT-0553
K-0001 OUTLET K-0001 DIFFERENTIAL PRESSURE K-0001 OUTLET SILENCER
TT-0550
K-0001 INLET
TT-0551
K-0001 OUTLET
TT-0552 TT-0210 LT-0072 FT-0067-B LT-0074 LT-0075 PT-0112
K-0001 OUTLET E-0036 VENT GAS SHELL SIDE OUTLET D-0017 AMINE ABSORBER KO DRUM LEAN AMINE FEED C-0007 AMINE ABSORBER C-0007 AMINE ABSORBER C-0007 TOP VENT GAS OUTLET
PT-0114
VENT GAS TO HEATER
PT-0456
VENT GAS TO HEATER
P&ID
UNITS
SA-JER-DS011TRJR-480090
%
SA-JER-DS011TRJR-480090
%
18.57 52.86
t/h
2.88
SA-JER-DS011TRJR-480091 SA-JER-DS011TRJR-480091 SA-JER-DS011TRJR-480091 SA-JER-DS011TRJR-480091 SA-JER-DS011TRJR-480091 SA-JER-DS011TRJR-480091 SA-JER-DS011TRJR-480091 SA-JER-DS011TRJR-480091 SA-JER-DS011TRJR-480091 SA-JER-DS011TRJR-480091 SA-JER-DS011TRJR-480092 SA-JER-DS011TRJR-480093 SA-JER-DS011TRJR-480094 SA-JER-DS011TRJR-480094 SA-JER-DS011TRJR-480094 SA-JER-DS011TRJR-480094 SA-JER-DS011TRJR-480094 SA-JER-DS011TRJR-480094
LL
L
H
HH 85.71
t/h
2.37
Barg
0.96
Barg
1.08
Barg
3.85
Bar
2.65
Barg
4.05
ºC
55
ºC
137
ºC
132
ºC
37
47
%
26
74
t/h
4.74
%
24.55 75.45
% Barg Barg Barg
6.06
93.94 0.7
2.5 0.55 1.0
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 71 of 244
TAG NUMBER TT-0217 PDT-0133 PDT-0134
SERVICE
P&ID
UNITS
C-0007 LEAN AMINE FEED G-0023-A SUCTION STRAINER G-0023-B SUCTION STRAINER
SA-JER-DS011TRJR-480094 SA-JER-DS011TRJR-480095 SA-JER-DS011TRJR-480095
LL
ºC
L
H
60
70
mbar
100
mbar
100
Table III.2-33: Alarms of Compressor/Amine Absorber Section
TAG NUMBER
SERVICE
P&ID
LV-0097
D-0016 OFF GAS COMPRESSOR KO DRUM
SA-JER-DS011-TRJR-480090
PV-0308
GAS RECYCLE FROM D-0017
SA-JER-DS011-TRJR-480090
LV-0070
D-0017 AMINE ABSORBER KO DRUM
SA-JER-DS011-TRJR-480093
FV-0067
C-0007 LEAN AMINE FEED
SA-JER-DS011-TRJR-480094
PV-0113
C-0007 TOP VENT GAS
SA-JER-DS011-TRJR-480094
LV-0074
C-0007 AMINE ABSORBER
SA-JER-DS011-TRJR-480095
Table III.2-34: Control Valve of Compressor/Amine Absorber Section
TAG NUMBER PZV-0048 PZV-0055 PZV-0550 PZV-0551 TZV-0007
SERVICE D-0016 OFF GAS COMPRESSOR KO DRUM D-0016 OFF GAS COMPRESSOR KO DRUM K-0001 VDU OFF GAS COMPRESSOR K-0001 VDU OFF GAS COMPRESSOR E-0036 CWR TUBE SIDE OUTLET
P&ID SA-JER-DS011-TRJR-480090 SA-JER-DS011-TRJR-480090 SA-JER-DS011-TRJR-480091 SA-JER-DS011-TRJR-480091 SA-JER-DS011-TRJR-480092
PZV-0033
C-0007 AMINE ABSORBER
SA-JER-DS011-TRJR-480094
PZV-0034
C-0007 AMINE ABSORBER
SA-JER-DS011-TRJR-480094
Table III.2-35: Relief Valves of Compressor/Amine Absorber Section
HH
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 72 of 244
III.2.10.
Utilities Section
The following utilities are supplied to the different consumers in the Crude Distillation unit: •
Low pressure steam
•
Medium pressure steam
•
Demineralized Water
•
High Pressure Boiler Feed Water
•
Soft cooling water
•
Auxiliary cooling water
•
Service water
•
Potable water
•
Nitrogen
•
Instrument air
•
Plant air
•
Fuel gas
•
Pilot gas
III.2.10.1.
Fuel and Pilot Gas
Fuel gas is supplied to the unit consumers after going through the Fuel Gas KO Drum, D-0015 (45ºC, 3.5 barg), where any liquid is disengaged from the gas. This drum shall be manually drained by the operator when high level alarm is detected by LI-0082. Pressure of the fuel gas is regulated by PV-0376 which is controlled by means of PC0376. Pilot gas is supplied to the Crude and Vaccum Heaters, F-0001 and F-0002, after going through a drip leg where any liquid is disengaged from the gas. This drip leg shall be manually drained by the operator when high level alarm is detected by LI-0136.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 73 of 244
Pressure to the pilots is controlled by means of PCV-0141 and PCV-0389 (set at 1.0 barg). III.2.10.2.
Condesate System
Medium pressure and low pressure condensates are flashed in the Drum, D-0026 (134ºC, 2.0 barg). The separated vapor is condensed by A-0008 and returned to drum, the accumulated condensate is sent to the battery limit through the LPC Pumps G0011A/B, with a level controller LC-0130 which controls the level in the drum manipulating LV-0130 in the discharge line. Pump is protected through flow controller FC-0195 (minimum flow recirculation). III.2.10.3.
Low Pressure Flare Network
The disposal of the PZVs discharges is done through a low pressure flare network. The liquid phase of those discharges is collected in the LP Flare KO Drum, D-0018, where the liquids are disengaged from the gases. Liquids are pumped from the drum through the LP Flare KO Drum Pumps, G-0026A/B, to the Slop Oil Tank, 681-T-0001A/B, through the E-0037 where the hot liquids are cooled down. Pump is started upon operator action while it is automatically stopped upon low-low level set point measured by LI-0088. Gases from D-0018 are sent to the battery limit where it joins with the refinery flare network. III.2.10.4.
Closed Drain
The disposal of the drains is done through a closed drain network. The liquids are collected in the Closed Drain Sump D-0014, and they are pumped from the drum by the Drain Sump Pump, G-0025A, to the Slop Oil Tank, 681-T-0001A/B, through the E-0037 where the hot liquids are cooled down. Pump is started upon operator action while it is automatically stopped upon low low level set point measured by LI-0084. The pump has an spare in the warehouse. When draining high viscosity fluids, which can plug the drains, it is required to flush the lines with flushing oil. In these cases, operator shall ensure the steam supply to the coil installed in the drum is open and shall pay special attention to the temperature measured in TT-0262 in order to avoid very high or low temperatures.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 74 of 244
Reference P&IDs SA-JER-DS011-TRJR-480201 through 480243
TAG NUMBER
SERVICE
LC-0130
D-0026 LPC DRUM
PC-0409
D-0026 LPC VENT
PC-0417
HPW FROM UNIT 691
TC-0233
DS-0003 MPS UTILITY DISTRIBUTION
PC-0376
FUG TO HEADER
P&ID SA-JER-DS011-TRJR480201 SA-JER-DS011-TRJR480201 SA-JER-DS011-TRJR480202 SA-JER-DS011-TRJR480202 SA-JER-DS011-TRJR480214
UNITS
SET POINT
%
50
bar
2.0
bar
12
ºC
270
bar
3.5
Table III.2-36: Controllers of Utilities Section
TAG NUMBER
SERVICE
LT-0131
D-0026 LPC DRUM
PT-0455
D-0026 LPC DRUM
PT-0265
MPS TO HEADER
PT-0267
LPS TO HEADER
PT-0377
HPW FROM UNIT 691
TT-0246
MPS TO HEADER
TT-0249
LPS TO HEADER
PT-0272
CWS FROM UNIT 691
PT-0379
SWA FROM UNIT 691
PT-0413
PWA FROM UNIT 691
PT-0276
LPN FROM UNIT 691
PT-0279
INA FROM UNIT 691
PT-0414
UTA FROM UNIT 691
LT-0082
D-0015 FG KO DRM
LT-0105
D-0015 FG KO DRUM
LT-0136
PIG DRIP LEG
P&ID SA-JER-DS011TRJR-480201 SA-JER-DS011TRJR-480201 SA-JER-DS011TRJR-480202 SA-JER-DS011TRJR-480202 SA-JER-DS011TRJR-480202 SA-JER-DS011TRJR-480202 SA-JER-DS011TRJR-480202 SA-JER-DS011TRJR-480207 SA-JER-DS011TRJR-480209 SA-JER-DS011TRJR-480209 SA-JER-DS011TRJR-480211 SA-JER-DS011TRJR-480211 SA-JER-DS011TRJR-480211 SA-JER-DS011TRJR-480214 SA-JER-DS011TRJR-480214 SA-JER-DS011TRJR-480214
UNITS %
LL
L
H
15.71 84.29
barg
1.0
barg
13.5
Barg
3.0
barg
57
2.8
ºC
325
ºC
200
barg
5.0
barg
3.5
barg
3.0
barg
8.0
barg
7.0
barg
6.0
%
18.57 52.86
% %
HH
85.71 26
74
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 75 of 244
TAG NUMBER
SERVICE
PT-0259
FUG TO HEADER
PT-0261
FUG TO D-0015
PT-0284
PIG TO HEADER
LT-0088
D-0018 LPF DRUM
LT-0106
D-0018 LPF DRUM
TT-0264
D-0018 LPF DRUM
TT-0265
D-0018 LPF DRUM
PT-0423
FLO TO HEADER
LT-0083 LT-0084 TT-0262
P&ID
D-0014 CLOSED DRAIN DRUM D-0014 CLOSED DRAIN DRUM D-0014 CLOSED DRAIN DRUM
TT-0370
SLP OIL TO BL
LT-0132
D-0025 AMD DRUM
LT-0133
D-0025 AMD DRUM
PDT-0422
S-0005 AMD FLTR
SA-JER-DS011TRJR-480214 SA-JER-DS011TRJR-480214 SA-JER-DS011TRJR-480214 SA-JER-DS011TRJR-480219 SA-JER-DS011TRJR-480219 SA-JER-DS011TRJR-480219 SA-JER-DS011TRJR-480219 SA-JER-DS011TRJR-480225 SA-JER-DS011TRJR-480232 SA-JER-DS011TRJR-480232 SA-JER-DS011TRJR-480232 SA-JER-DS011TRJR-480232 SA-JER-DS011TRJR-480233 SA-JER-DS011TRJR-480233 SA-JER-DS011TRJR-480233
UNITS
L
H
Barg
3.0
4.7
barg
4.0
barg
4.0
%
LL
11.11
%
12.94 22.35
ºC ºC
15
170
10
barg
210 13.6
% %
22.22 94.81 5.56
ºC
165
ºC
170
% %
33.33 86.67 6.67
bar
0.5
Table III.2-37: Alarms of Utilities Section
TAG NUMBER
SERVICE
P&ID
FV-0195
LPC TO D-0026 LPC DRUM
SA-JER-DS011-TRJR-480201
LV-0130
D-0026 LPC DRUM
SA-JER-DS011-TRJR-480201
PV-0409
D-0026 LPC DRUM VENT
SA-JER-DS011-TRJR-480201
PV-0417-A
HPW FROM UNIT 691
SA-JER-DS011-TRJR-480202
PV-0417-B
HPW FROM UNIT 691
SA-JER-DS011-TRJR-480202
TV-0233
DS-0003 MPS UTILITY DISTRIBUTION
SA-JER-DS011-TRJR-480202
FG TO HEADER
SA-JER-DS011-TRJR-480214
PV-0376
HH
Table III.2-38: Control Valve of Utilities Section
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 76 of 244
TAG NUMBER
SERVICE
P&ID
PZV-0063
D-0026 LPC DRUM
SA-JER-DS011-TRJR-480201
PZV-0064
D-0026 LPC DRUM
SA-JER-DS011-TRJR-480201
PZV-0062-A
BFW BATTERY LIMIT
SA-JER-DS011-TRJR-480202
PZV-0062-B
BFW BATTERY LIMIT
SA-JER-DS011-TRJR-480202
PZV-0094-A
BFW TO MPS HEADER
SA-JER-DS011-TRJR-480202
PZV-0094-B
BFW TO MPS HEADER
SA-JER-DS011-TRJR-480202
PZV-0044-A PZV-0044-B PZV-0093
D-0015 FUEL GAS KO DRUM D-0015 FUEL GAS KO DRUM FLO BATTERY LIMIT
SA-JER-DS011-TRJR-480214 SA-JER-DS011-TRJR-480214 SA-JER-DS011-TRJR-480225
Table III.2-39: Relief Valves of Utilities Section
III.3. Process Variables This section describes the most important process variables which control the operation of the CDU/VDU.
III.3.1. Desalter
III.3.1.1. Crude Feed Rate The crude feed rate to the CDU/VDU is controlled by FC-0006 at Preflash column inlet. The control loop includes an override from PC-0007 for prevent vaporization of the crude in the desalter. Any change to the feed rate shall be done gradually to allow the unit to adjust to new capacity. For major changes in the rate, it should be required to also adjust product draw-off to keep the yields, tune-in pumparound to reestablish the optimum temperature profile in the column, modify desalting water flow, chemical injections, etc.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 77 of 244
III.3.1.2. Desalter Inlet temperature Higher temperature reduces crude viscosity and promotes coalescence of brine. On the other hand, too low temperature causes defective contact between water and crude, stabilization of emulsion and coalescence difficulty; reducing the performance of the desalting process. As the crude preheating heat exchangers loses efficiency due to fouling, the crude temperature gradually falls below 148 ºC level. This shortcoming can be corrected by adjusting the crude feed preheat train. III.3.1.3. Desalting Water Rate Desalting Water rate affects directly the salt dilution in crude oil and then the salt content in the desalted crude. While the Desalter design and operation is based on desalting water at 6%vol of crude or 92 m3/h, the water system is designed to deliver 116 m3/h maximum. By mixing with more desalting water, dissolved salt will be more readily extracted thereby increasing the efficiency. However, the water rate increase must be weighed against the increased load to the Waste Water Treatment unit. III.3.1.4. Mixing Valve Pressure Drop Pressure drop of mixing valves, PDV-0005 and PDV-0006, should be monitored in conjunction with the desalter performance as well as degree of stable emulsion formation. Valve pressure drop should be set at 1.0 bar. Too much pressure drop tends to increase the stable emulsion, while too little pressure drop will not disperse water uniformly in the crude.
III.3.2. Preflash Column
III.3.2.1. Inlet Temperature The inlet temperature determines the fractionation in the preflash column. It also balances the naphtha flow rates separated from the preflash and from topping column.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 78 of 244
MP striping steam increases the column temperature. The inlet temperature is set at 200 ºC. The normal steam flow rate is 4.5 t/h. III.3.2.2. Column top pressure The column top pressure is defined by the control pressure PC-0021 on the Preflash Reflux Drum, D-0003. In order to maintain the column top pressure at 3.7 barg, drum pressure shall be set at 3.0 barg approximately. III.3.2.3. Column overhead temperature The column overhead temperature defines the cut point of the Preflash Naphtha. The temperature controller TC-0101 regulates the crude bypass of E-0004. The temperature is set at 137ºC in order to keep a gap higher than 20 ºC above the water dew point. The reflux flow rate and ratio are fixed by the level control LC-0004 of D-0003, and it is a consequence of the temperature.
III.3.3. Atmospheric Column
III.3.3.1. Feed Temperature and Overflash The Crude Heater outlet or column feed temperature defines the flash zone temperature and the overflash flow rate. With the feed temperature set at 366ºC, the desired product vaporization is achieved with 7 %wt of overflash. The overflash should be maintained so as not to overload the Vacuum Column with atmospheric distillate. III.3.3.2. Column top pressure The column top pressure is defined by the control pressure PC-0033 on the CDU Reflux Drum, D-0004, where non-condensable are vented or fuel gas is injected. In order to maintain the column top pressure at 1.0 barg, drum pressure shall be set at 0.3 barg approximately.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 79 of 244
As pressure increases, the relative volatility approaches to unity. This means that the boiling points of the components are more similar, and, therefore, it is more difficult to separate them. Also, it will reduce the overflash and therefore the internal column flow and the separation achieve will be lower. III.3.3.3. Column Overhead Temperature The column overhead temperature defines the cut point of the Atmospheric Naphtha. The reflux flow rate (and ratio) is controlled in cascade by the temperature controller TC-0101, set at 119ºC normally. The overhead temperature shall be enough high to allow a total vaporization of the naphtha. A lower temperature will cause part of the top product condenses and goes into the Kero draw-off. A higher temperature will send fractions with high boiling point to the top naphtha stream. III.3.3.4. Side Stripper Draw-Off Rates The main specifications to which the products from fractionator can be adjusted are the boiling point ranges and the flash point. In general, if the fractionation is good, the end boiling point of a side-cut equals the initial point of the next heavier product plus a gap. A gap is the result of a good fractionation; however overlap is more normal and will increase as fractionation efficiency decreases. Product withdrawal flow rate are adjusted to provide the required end points for the products and are generally set up from the top of the column working down. As a general rule, increasing the draw off rate will raise the end point of the side stream cut whilst decreasing the draw off rate will lower its end point. An indication of the end point is the draw off temperature of the stream leaving the column. Increasing the product withdrawn, means that increases the draw off temperature and the product end point. The side product draw-off rate must be carefully balanced to meet the distillation quality, while maximizing the valuable product yield. Flash point of LAGO and HAGO products can be modified by adjusting the flow of stripping steam via FC-0027 and FC-0028 respectively (to increase the flash point, the stripping steam has to be increased). However, the stripping steam can only be
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 80 of 244
increased to the point where it begins to interfere with the end point of the next higher product. If a further increase in the flash point is required, other changes have to be made, allowing an increase of the end point of the next higher product. The Kerosene flash point can be adjusted by modifying the temperature of the kero side outlet of reboiler E-0022. The controller TC-0121 controls in cascade the HAGO PA flow rate that passes through the reboiler. The specific gravity is directly related to the initial and final product boiling point, so, changing the products yields, requires achieving this specification. The freeze point is related to chemical composition of the product. As final boiling point increases, the paraffin content in the product increases too, so the freeze point obtained will be higher. If residue entrainment occurs, the HAGO product can get black color. This means that the section, between HAGO draw off tray and flash zone, does not have enough liquid flow. It is necessary to increase the overflash or reducing the HAGO draw off rate. III.3.3.5. Pumparound Duties Pumparounds are critical to maintain the optimum temperature profile and vapor/liquid rates in the fractionation of the column and to obtain the specific products. Pumparound duty is regulated by controlling the flow rate and the return temperature of each one. Inadequate pumparound heat removal and poor pumparound distribution will result in high column pressure, poor fractionation and an increase of pressure in the flash zone. Excessive pumparound heat removal may result in difficulties in maintaining some end point and may cause internal flooding. III.3.3.6. Bottom Striping Steam The purpose of stripping the Atmospheric Residue is to reduce the atmospheric distillate escaping to the Vacuum Column. It is suggested that for hydraulic stability of the stripping trays, the design stripping steam rate be maintained regardless of the crude throughput. The steam flow rate affects the flash zone temperature and the overflash. The normal stripping steam should be 20.2 t/h.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 81 of 244
III.3.4. Vacuum Column
III.3.4.1. Feed Temperature and Overflash With the Vacuum Heater outlet temperature set at 407ºC, the desired product lift is achieved with a 5 %wt of overflash, providing 0.4 – 0.5 m3/hm2 of wash oil at the bottom of the packed bed in the wash zone. Overflash or wash oil rate is one of the most critical operating variables of the column. If not maintained as designed, the packed bed will run dry, resulting in a heavy deposit of cokes on the packing. The coke deposits then leads to mal distribution of liquid and vapor. This circumstances cause a reduction of the overall efficiency of the fractionation, an increased vapor pressure drop in the wash zone and an increase of impurities in the HVGO fraction, resulting in high metal and carbon contents in the feed to the DHC/MHC. III.3.4.2. Flash zone pressure Flash zone pressure is controlled by the spillback controller from 1st Stage Ejectors, J0001A-C to Precondenser E-0025A-D inlet. The lower the pressure, the lower the heater outlet temperature will be to accomplish the desired lift. The lower heater outlet temperature alleviates the potential coking problem, so it is desired to keep the pressure as low as possible. However, in lower pressure, the vapor traffic increases, and the higher vapor velocity through the flash zone and liquid entrainment would counteract the benefit. III.3.4.3. Bottom Striping steam Unless insufficient stripping of the Vacuum Residue product, stripping steam flow rate should not be increased as it raises the column pressure drop as well as the load to Precondensers E-0025A-D, and the sour water to SWS unit. In normal conditions, striping steam should be 17.6 t/h. III.3.4.4. Bottom Temperature The temperature of vacuum column bottom is maintained at 360 ºC to minimize coking. The quench flow should be increased by setting a lower temperature on the bottom temperature controller TC-0204. The liquid residence time in the bottom column is
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 82 of 244
limited to 5.5 min at HLL, in order to reduce coke deposit in the column bottom and the pump suction circuit.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 83 of 244
IV. PREPARATION FOR INITIAL START-UP This section defines the general preparatory works and procedures required in preparing the unit 02020-011 for the start-up, it has been written following the highlights activities and phases given in the Licensor Operation Guidelines. The final preparation described hereafter is carried out when all construction work including hydro test is completed and the unit is completely blinded at all battery limit locations, and equipment is generally reinstated, closed to atmosphere and is unpurged. Prior to achieving readiness for unit start-up, all Precommisionning and Commissioning work shall be carried out and accepted. Similar activities are required for a start-up following a turnaround overhaul. Other start-up from cold will incorporate preliminary checks as appropriate. The Start-up activities begins with the final preparation to the introduction of the feedstock into the plant and consist of a series of various tests carried out during the plant is brought on line. The aim of these tests is to ensure that all equipment operate normally and securely. The field activities consist of two sub-stages: Operate prior oil/gas in: Line up pipe work and vessels (valves, PSV, interlocks, etc.), carry out final safety tests with the provision of associated documents (safety procedures, isolation, inhibition, HC introduction certificate if needed, etc.). Operate after oil/gas in: bring the process in operation with Oil/gas-in, water injection, ensure the ramp-up and carry out the Performance tests to prove the plant and equipment are performing as per design capacities and can deliver the products within specifications.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 84 of 244
IV.1. General Pre-commissioning is the preparation of constructed facilities to achieve Mechanical Completion status. Pre-commissioning establishes the required status for the commencement of functional or dynamic tests. It involves the examination and checkout of individual components, and is generally carried out on equipment and material in a static condition. It confirms continuity and containment of process flow routes, achieves appropriate cleanliness of all plant internals, and checks each item of process equipment for physical integrity and its suitability for service. Most of the activities are carried out with the facilities under ambient atmospheric conditions, well before they are subjected to process fluids. Pre-commissioning will be carried out as parallel single discipline activities in conjunction with final erection. The pre-commissioning will be managed within a construction controlled site safety regime. Where practicable there is a high level of integration of construction disciplines in the execution of the pre-commissioning scope. For instance the water flushing, air blowing and final reinstatement of piping may be fully integrated with the hydro test program. The pre-commissioning scope of activities is such that it can be safely and effectively carried out in parallel with the latter stages of construction. This results in benefits to overall schedule. In general, pre-commissioning does not involve dynamic operation of process equipment. With the purpose of facilitating the pre-commissioning activities and surrenders, the plants have been divided into systems, both operational and non-operational. Operational systems are dynamic process oil and gas, utility, or facility systems such as high pressure steam, gas oil, cooling water, low pressure flare header, telecom, electrical or control systems.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 85 of 244
The different Operational systems for the CDU/VDU Unit 02020-011 that has been considered are: System Description CRUDE/VACCUM DISTILLATION UNIT
ICAPS ICAPS Sub-System No: System No: ZZnn J011
57
J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011 J011
J0110101 J0110102 J0110103 J0110201 J0110202 J0110203 J0110204 J0110205 J0110206 J0110207 J0110208 J0110209 J0110301 J0110302 J0110303 J0110304 J0110305 J0110306 J011LF00 J011UN20 J011UN30 J011UL20 J011UL30 J011UG00 J011UB00 J011UB10 J011UR00 J011UQ00 J011UM00 J011UZ00 J011UU00 J011UA11 J011UA12 J011UA13 J011UA14 J011UD00 J011UF00 J011UH00 J011UI00 J011UI10 J011UI20 J011UJ00 J011UK00 J011UO00 J011UY00 J011UW00 J011SA00 J011SB00 J011QA00 J011QD00 J011MB00 J011ME00 J011PA00 J011PI00 J011PS00 J011JI00 J011JV00
Sub-system Description:
Feed to Crude tower: Feed until desalters Feed to Crude tower: Desalters Feed to Crude tower: Preflash tower Crude Tower: Crude Furnace Crude Tower: Crude Tower Crude Tower: HAGO to Storage Crude Tower: LAGO To storage Crude Tower: Kerosene to storage Crude Tower: HAGO Pumparound Crude Tower: LAGO pumparound Crude Tower: KERO pumparound Crude Tower: Crude tower head Vacuum Unit: Vacuum Furnace Vacuum Unit: Vacuum Tower Vacuum Unit: HVGO Vacuum Unit: LVGO Vacuum Unit: Vacuum Head Vacuum Unit: Amine Colum Closed Drain Piping Steam Medium Pressure Steam Low Pressure Condensate Medium Pressure Condensate Low Pressure Steam Tracing Cooling water supply and return - Main Cooling water supply and return - Auxiliary Utility air Instrument Air Boiler feed water Slops Flare Chemical Dosing: Phosphate Injection Chemical Dosing: Demulsifier Injection Chemical Dosing: Corrosion Inhibitor Chemical Dosing: Neutralizing Agent Fuel Gas Nitrogen Fire Water Service water Desalting water Tempered water Potable Water Demi Water Pilot Gas Flushing Oil: Flushing Oil Sour Water Closed Drain and Paving Civil Work Foundations - Main Piperack and Structures - Main Platforms, Structures and Supports - Miscellaneous Fireproofing Grounding and Lightning Lighting and Cable Trays Cathodic Protection Fire and Gas Analyzer Instrument Cabinet
SATORP Unit No: 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011 011
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 86 of 244
Non-operational systems are systems such as surface and passive fire protection, insulation, architectural, structural steel, markings and signs, cable / tubing trays and ladders. These non-operational systems will be completed through geographical areas. These systems will be included in specific packages, previously agreed upon with the Company, and will include all the possible disciplines of the project. In this respect, all the possible constituents of the plant will be categorised under a certain and specific system and this system itself will be linked to a determined partial mechanical completion package. Mechanical Completion shall be staged by System and shall ultimately apply to an entire process unit or to a specific defined geographical area as necessary to allow the commissioning activities to follow efficiently and safely. Mechanical Completion (MC) is the point when a defined portion of the facilities is fabricated, fully erected, all materials items are present and aligned, tested for physical strength, and all pre-commissioning checks completed. In practice MC status shall be apply to a single specific System or a defined Mechanical Completion package containing several Systems. Achievement of MC is staged to a target sequence. MC status requires that: •
All material items are fabricated, present, erected, aligned and finally instated according to specification.
•
Material dimension, composition and mechanical strength is documented and on-site tested as specified by technical standards.
•
Vessel internals, bulk packing, catalyst beds (where safely practicable) and all machinery components are installed and appropriately preserved.
•
Internal cleanliness is achieved, with dry preservation maintained.
•
All components parts are fully reinstated aligned, and containment status is achieved.
•
Energised checks are performed on electrical and instrument items.
•
Control systems site acceptance tests are complete.
•
Instrument full loops are checked for correct actions and logic sequence.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 87 of 244
•
Energised tests on switchgear and cabling are complete.
•
The correct functioning of equipment ancillaries is demonstrated where practicable.
Ultimately the MC status will apply to the entire scope of the facilities. In addition to the above, for a portion of the facilities to be considered as Mechanically Complete, the following accompanying status will be completed: •
Agreed commissioning spare parts available for all vendor equipment.
•
All “A” items by TR and Company are completed.
•
All non-conformance reports resolved to the satisfaction of Company.
•
All fabrication and construction documents, material certificates, inspection and test records, equipment inspection and preservation schedules, and precommissioning documentation shall be completed, catalogued, and available for review.
The inspection test and certification documents will be within a Dossier for each Mechanically Complete System or Package and offer for approval by Company. The adequate pre-commissioning checks and tests will be performed on every item of the plant, and conveniently reported through the use of Pre-commissioning Forms on completion of these checks and tests.
IV.1.1. Check Lists
First type of task of the precommissioning scope of work, the Conformity Checks are carried out in accordance with, and reported on, Check Lists. Conformity Checks are carried out on each item of equipment or component, such as instruments, packages, motors, cables, vessels, etc., to verify visually the condition of the equipment, the quality of the installation, the compliance with Project drawings and specifications, VENDOR's instructions, safety rules, codes, standards and good practice.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 88 of 244
These Check Lists define the exact scope of work that must be systematically performed on every item of equipment, the same support being also used to record the checks. One check list is filled in per subsystem and per type of equipment for each discipline.
IV.1.2. Test Sheets
Second key precommissioning activity, the Static and de-energized Tests are carried out in accordance with technical specifications, and reported on Test Sheets. Static/de-energised Tests are carried out on equipment to ensure the quality of a number of critical components. These “cold” testing concerns all disciplines, e.g. calibration of ESD instruments, machinery alignments, setting of safety valves, pressure testing of piping, cables continuities, etc. Throughout the document, all the related parts leading to MC will be conveniently reported. One Test Sheet is filled in for each test performed.
IV.1.3. Piping Test (Test Pack)
Third key Precommissioning activity, the Tests pack shall group Precommissioning activities on pipes work and vessels such as air or water flushing, pressure test (hydrotest).
IV.2. Inspection Program The plant should be carefully checked to assure that is constructed according to applicable plans, drawings and specifications. A check off against the P&ID diagrams is done for piping, equipment and instrumentation. A “punch list” of missing, incomplete or incorrect items is then prepared for correction. In addition temporary identification tags, signs for various lines, valves and equipments can be installed at this time to assist in subsequent start-up and operation.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 89 of 244
This check is carried out before the end of construction work in order to check that the unit is satisfactory from an operation point of view. All the individual operations needed for precommisioning, start-up and shutdown the units are applied on site. Smooth start-up will depend to a large degree on the thoroughness with which the unit is checked out beforehand. Every installation details must be checked against the design specifications and standards and for good constructions practice. A first list of applicable checks to be performed is given here below: Non-return valves, control valves, certain globe valves Ensure these are installed with the flow direction arrow (stamped or tagged on the valve body) in the correct direction. All valves •
Check that packing followers are correctly tightened and that the valves open and close smoothly.
•
Stuffing boxes of valves are adequately filled.
Sample connections •
Are these correctly placed, i.e., not in a dead-end?
•
Are they of the type indicated on the P and P&ID, i.e., double valve, block and needle, etc.?
•
Is there room enough to insert the sample bottle?
•
Are sample coolers correctly piped-up?
Pump suction strainers •
Can the strainer body be depressured and drained?
•
Can a drain hose be coupled to the drain connection without problem?
•
Is there enough room to insert a bucket or can underneath the drain point?
•
Can the strainer be pulled without problem?
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 90 of 244
•
Check nameplate rating and conformity to project specifications and design requirements.
•
Check the rotating equipment, supports, insulation, flanges, expansion joints and piping connections.
•
Check and inspect lubrication systems.
•
Check foundations bolts and shims.
Piping low points, high points and slopes •
Check these are in accordance with the P&ID, that drains and vents are installed and equipped with plugs.
Pipe supports •
Check spring hanger transit pins have been removed.
•
Check slipper pads are situated correctly in their guides.
•
Check pipe clamps are tight.
Stream traps •
Ensure these are correctly installed and that they blow to a safe location.
•
Check integrity of isolation and bypass valves.
Safety valves •
If these vent to atmosphere, check that the exhaust line is adequately supported and drainable if there is low point. If paired safety valves with a key lock system are installed, check the lock system is in good order and that the keys are available and labeled.
Insulation •
Check that piping insulation on hot and cold service lines is in good condition and has been completed; in some cases insulation may not be completed until
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 91 of 244
just prior to start-up. Check that the insulation cannot become saturated with water during flushing operations or inclement weather. Earthing •
In some piping applications flanges are coupled by an earthing strap, check integrity of strap and connections.
Gaskets and joints •
If soft metal ring joint flanges are installed, ensure that a check has been carried out, during Precommissioning, of flange face integrity. This type of flange/joint is often used in hot, high temperature service, such as catalytic reformer reactor Inlet/outlet flanges. Where spiral wound gaskets ("metaflex", etc.) are employed, it is important to check that the correct rating has been employed.
•
If pipe work is to be dismantled for flushing, this type of gasket is frequently replaced, temporarily, by an asbestos compound gasket. The correct gasket must be installed prior to handing over the system for start-up.
Blinds At the ready for Commissioning stage a blind list must have been prepared by the Precommissioning team. If this is not the case, and blinds have been installed, it is most important to initiate a blind list at the earliest possible moment. The principal reasons for a blind list are as follows: •
To record where the blinds are situated and why.
•
To ensure that the blinds are removed prior to start-up.
In the case of spectacle blinds and certain other blinds, it may well be necessary that these remain in position at the time of start-up; however, a battery limits blind list will be issued prior to start-up in order that blind status may be readily checked. The blind list will contain the following information: •
Line number (ex.: P&ID), size and service.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 92 of 244
•
Blind number.
•
Blind size and rating, i.e. 150, 300, etc.
•
Date installed plus signature.
•
Date removed plus signature.
It is often the case that blinds are installed, during Construction and Precommissioning, for hydrostatic tests, flushing, etc., and these are frequently forgotten if not correctly listed. It also happens that blinds without tags (handles) are installed; in this case it is extremely difficult to tell the difference between a blind and the edge of spiral wound metal gasket. Therefore, blinds will always have a tag or handle clearly labeled for easy identification. Accessibility •
Check accessibility of valves and other equipment. Not accessible valves located in pipe racks, will be equipped with chain wheels and chains, or extended spindles.
Safety •
Check all safety aspects related to piping, i.e. protruding valves spindles.
Operability •
Check operability aspects, such as the location of pressure gauges installed at pumps discharge that must be readable while maneuvering the discharge valves, the level gauges of capacities to be visible from the drain valves locations, etc.
•
Check the presence of the required start-up and pressurization lines as well the impact of the safety devices on start-up operations.
Spectacle blinds •
Can they be swung easily?
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 93 of 244
•
Are they installed in such a way that they can be swung without a shutdown, i.e. between double block and bleed valves.
Drums and exchangers inspections •
Conformity with project documentations.
•
Pressure, temperature, rating.
•
Allowable for thermal expansion.
•
Internals types, dimensions and material per spec.
•
Lining & insulations type, thickness, material. Check integrity of insulation.
•
Instrument nozzle and type.
•
Location and size of ladder, platform, man ways. Check access ladders and platforms are correctly installed and in good order.
•
Code plate information.
•
Test certificate; grounding connections.
•
Vents, drains relief valves per spec.
•
Thermo well locations and length of immersion.
•
Check maker's nameplate details are correct.
•
Check nozzles and man ways are as shown on updated P&ID and engineering drawings.
•
Ensure fire detectors, sprinklers, deluge systems, foam heads are correctly installed.
•
Carefully inspect the outer skin of pressure vessels to ensure that at no time has unauthorised welding taken place; sometimes scaffolding is temporarily tack welded in place by mistake. Most pressure vessels are marked "no welding" to avoid such mishaps but nevertheless one can never discount human error. If such a case is discovered, the vessel in question should be handled back to the construction team for rectification, i.e. stress-relieving, non-destructive testing, etc.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 94 of 244
In situations where manways are specified in baffles in particular vessels, a check will be made to ensure that these manways are actually installed with appropriate bolting and gaskets, as specified on the drawings. •
Ensure all foreign bodies have been removed from the vessels and vessels skirts. This includes scaffolding, ladders, tools, etc.
•
Check especially that wire mesh pads, vortex breakers, weirs, baffles and any other internals are in place and that they are securely attached and of the correct dimensions.
•
It is not anticipated that any change will be required on any of the towers or vessels, or to the drawings. However, absolutely no changes are to be made or approved in the field.
Towers, Columns •
Verify all towers and vessels are clean and free of any debris, excess rust, etc.
•
(for the most part this requires hand cleaning).
•
Check that man way gaskets are of proper size and materials, and that manway
•
studs/bolts are properly tightened.
•
Verify types of trays and types of valves in tray decks.
•
Check tray support rings for welding and dimensions.
•
Make sure that tray valves are not corroded or stuck.
•
Check down comers for proper vertical alignment and clearance between bottom of down comer and deck plate.
•
Check tray overflow weirs for proper dimensions and welding/bolting.
•
Check bolting of tray segments to support rings - these must be tight, and in some cases, the underside nuts require tack welding. Verify this against the drawings.
•
Check tray decks, tray valves, and all internal bolting for proper materials of construction. Bolting must also be checked for proper size and installation of washers. Verify tower/vessel materials of construction.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 95 of 244
•
Check each tray deck for horizontal deflection. Decks should be flat within a tolerance of plus or minus 0.5%, measured at four equidistant points with a spirit level.
•
Check that splash weirs are installed, and that they are properly secured by bolting or welding, per the drawings.
•
Verify that required tray gaskets are properly installed, and that they are of the proper materials.
•
Verify that all nozzles are open from the inside of the tower and that they are neither plugged nor restricted with foreign articles, dirt, etc.
Inspection preparation works for Reactors, drums and towers: Here bellow is the description of the preparation work to be carried out to allow access to the internals. •
Columns, Drums and Vessels: Isolated by blinds from any potentially dangerous source (Flare, fuel gas, hydrogen, N2, chemicals, HC…).Man ways and vents open, atmosphere breathable. Internals assembled.
Pumps inspections •
Conformity with project documentations.
•
Piping arranged to allow dismantling of pump and driver.
•
Suctions strainer easily removable for cleaning; strainer cartridges properly fitted so no bypassing can occur; strainer installed.
•
Accessibility of auxiliary piping and controls.
•
NPSH requirements applied.
•
Steam tracing and insulation provided on suction/discharge lines, pump casing and process seal flush lines as required.
•
Minimum flow bypasses (with restrictions orifice) if required.
•
Lubrications and cooling system operate correctly.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 96 of 244
•
Vacuum service pump fitted with discharge vent back to system to allow filling pump with liquid.
•
Pumps and driver alignment correctly.
•
Lube /seal oil system: operability of all sight flow indicator, instrumentation, pumps (including auto start), filters, coolers, pumps trips, reservoir, and seal oil pot, etc. Addition and removal of seal/lube oil to/from reservoir can be done easily.
•
Insulation for heat conservation and personnel protections, as required.
Heaters inspections •
Ensure refractory brickwork and burner are in good order.
•
Check ductwork refractory condition (normally sprayed-on cement coatings such as "GUNNITE"). Ensure all wooden formwork used for castable refractory is removed and no obstructions are present in the ducting or stack.
•
Ensure free movement of stack dampers.
•
Check furnace tube hydrostatic test has been completed.
•
Verify Heater header boxes and air leak paths sealed.
•
Burner alignment, tips checked and proven clean.
•
Fuel gas lines blow clean and dry.
•
Fuel isolation device checked and tested.
•
Damper and air registers checked for free movement.
•
Draft gauge and stack gas O2 analyzer installed and tested.
•
Heat refractory has been cured, dried out and inspected.
•
Check if tube top seals of all points are allowed free expansion.
•
Check that catalyst tubes are externally clean.
•
Check convection section for flue gas bypassing.
•
Check inlet pigtails for correct support, counter –weight and free expansion.
•
Check outlet pigtails for correct support, counter-weight and free expansion.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 97 of 244
•
Check that tube tops outside the reformer are not insulated.
•
Check if all spring hangers and/or counter-weights are correct and correctly installed, shipment stops removed and set at correct weight.
•
Check peek hole projection so that all tubes and burners can be seen.
•
Check that refractory –lined part of transfer line/process gas boiler is not insulated.
•
Check flue gas ducting expansion joints for sealing and not too tight.
Piping inspections •
Conformity with project documentations.
•
Dimensions.
•
Pipe: flanges, gaskets, fittings, valves in conformity with specified piping classes.
•
High points vents and low points drains; pipe support and spring hangers.
•
Insulation: type, thickness, material.
Electrical Inspection List Some of the required electrical tasks to be developed during the pre-commissioning phase are: •
Contractor shall subcontract a specialized company for the rele calibration, needing meanwhile COMPANY´S supervision.
•
Medium and high voltage cables will be dielectric strength tested (2 ½ times the nominal voltage).
•
Temporary electrical facilities shall be given up for testing.
•
Low voltage strength cables will be continuity tested and insulated 100% while control cables will only be insulated up to 100%.
•
Once the bars assembling of the cells, MCC´s and strength centers are done, a dielectric strength test will be performed for each connection and also a general one.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 98 of 244
•
Power distribution and MCC will be functionally tested and proven energized.
•
Panels, medium voltage and 480V cells will also need to be tested.
•
Grounding tests are also required.
•
Electric subcontractor will perform pre-commissioning tests in field electric equipment such as motors, developing the following tests: o Winding continuity measures. o Motor insulation. o Motors turn direction, revolutions, vibrations, etc.
Following tests shall be performed in the factory under the supervision of the equipment reception responsible: •
Opening and closing of switches.
•
Trips on the switches.
•
Lamp tests.
•
Alarm tests.
Instrumentation Inspection List Tests and checks on field and panel-mounted instruments shall take place in three stages, not necessarily according to temporal sequence: 1st stage: Instruments calibrations checks and tests Checks and tested belonging to this stage are mainly intended to detect possible damages occurred during transport and/or storage of the instruments and to verify manufacturer’s shop calibration. The calibration checks will vary depending to the instrument type. 2nd stage: Instruments installation checks At this stage, hydraulic pressure or pneumatic leak tests shall be performed to ascertain absence of leaks on the instruments process connections and on instrument air feed
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 99 of 244
sub-manifolds. During the pressure tests, instruments shall by duly isolated by means of blocks valves. At the same time, the following inspection shall be performed to determine that: •
Locally mounted instrument (pressure gauges, temperature indicators, gauge glasses, etc.): Verify condition, installation, range, visibility, accessibility, rating, trace heating and insulation where applicable. Check drainage facilities.
•
Other equipment (pressure transmitter, magnetrols, thermocouples, etc.): Check condition, installation, accessibility, conformity. When applicable, check valves, connections, isolation, drainage, insulation and trace heating, cable trays segregation.
•
The instruments are in the right locations and positions.
•
Mechanical and electrical connections conform to projects specifications.
•
Control valves and rotameters are correctly positioned and properly oriented “in line” according to flow direction.
•
All other valves and non-return valve orientations are correct.
•
Orifice upstream and downstream piping runs, orifice taps locations and orifice size, conform to projects specifications.
•
Drains, purge systems, winterizing and isolation valves are properly installed.
•
By-pass and block valves are installed as required by the project.
•
All process connections have been correctly installed as far as slope, insulation and steam tracing are concerned.
•
All control valve positioners are properly secured to the valve stem. The actuators allow an easy maintenance and accessibility.
•
Junction box are wired and installed as per specifications and layouts.
Safety valves should be calibrated, certified, documented and properly installed as specified. Contractor shall carry about the set pressure check using an adequate test bench. Safety valve pressure setting shall be in accordance with project specifications. The setting certificate will be approved by the Client Representative and by the local Authority Representative.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 100 of 244
Besides the following checks should be performed: •
Seals and tags installed as specified.
•
Isolations valves installed in open positions and open/closed standby valve lined up as required.
•
Locking and interlock devices checked for operation and relief valve register/checklists completed.
The Safety Interlocks (ZC) is independent system, which in the case of occurrence of predefined potentially harmful events initialize various actions such as: •
Valves are set to their failure position (AFO, AFC and AFS).
•
Shutdown of equipment (pumps, compressors, furnaces, etc.) to alleviate the risk.
The principles of these checks are as follows: a simulated default signal from the primary sensor will be fed into the system and the resulting signal output to valves or equipment will be checked. Whenever possible, the result of the signal output such as actual valve closure or machine shutdown will be observed. Ultimately, a real test, which requires running machines, must be performed during the forthcoming operation procedures. Throughout this exercise, the actual physical position of the valves (or status of machines) will be checked against the indications shown in the control room. The check of the motorized valves is part of the same task. It includes: •
A site test of the opening/closing of the valve upon the input signal.
•
A control room checks of the reported indication and a check of the control room command.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 101 of 244
Analysers: Testing and calibration shall be carried out by the TR under the Vendor specialist/main contractor general instruction. Control Valves: Check that the valve action is correct and that on air failure is correct. Control valve packing should be properly adjusted after the valve is placed into operation. Do not tighten packing for the tightness tests. Thermowells: Must be checked for proper position and immersion in the fluid, and for proper insulation to stop heat leaks around thermocouple or thermometer bulbs. Emergency Isolation Valves: Activate all emergency isolation valves operate according to specified time via local and/or remote switches. Check valve closure time. Gas Detectors: Combustible gas detectors detection systems must be checked.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
IV.2.1. Check List Sheets
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 102 of 244
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 103 of 244
PRECOMMISSIONING CHECK LIST MECHANICAL HEAT EXCHANGER P01 - (SHELL AND TUBE)
*J40003720* *J40003720* FORM :
1
Check that the nameplate details are both correct and compete.
2
Check the location, elevation, orientation and that the exchanger is level.
3
Check that the holding arrarngements are correct (eg., the sliding end.).
4
Check for any installation damage.
5
Check the exchanger is installed as per approved drawings.
6
Remove the transport bolts from the bellows ( if applicable).
7
Check the painting visually for any damage.
8
Check the exchanger is bonded as per approved drawings and specifications.
9
Check the exchanger pipe supports are as per approved design.
10
Check with disconnected pipework flanges that the relative nozzle flanges are correctly aligned.
11
Check that the channel cover can be removed.
12
Check that it is possible to withdraw the tube-bundle (if applicable)
13
Check that the bolting is suitably lubricated.
14
Check preservation is carried out as per approved procedure.
15
Produce a set of marked-up drawings in accordance with the installation.
16
Produce a defects list to be included in the Punch List issue.
REMARKS:
PUNCH LIST ITEMS
J10022054
Item : 011-E-0003-D
J10022052
Item : 011-E-0003-C
J10022050
Item : 011-E-0003-B
J10022048
CHECK LIST
Item : 011-E-0003-A
ITEM
J10022046
Subsystem J0110101
Item : 011-E-0002
0,6
EXPENDED TIME (MH) :
J10022044
ONSHORE
ESTIMATED TIME (MH) :
Item : 011-E-0001
CEX01 - HEAT EXCHANGERS (SHELL & TUBE)
TASK LOCATION :
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 104 of 244
SAME CHECK LIST SHEETS WILL BE USED FOR THE FOLLOWING ITEMS:
SUBSYSTEM J0110101
J0110102
J0110103
J0110201
J0110203
J0110204
J0110205
011-E-0001
011-E-0032A/B
011-E-0010A/B
011-E-0040
011-E-0035
011-E-0024
011-E-0022
011-E-0002
011-E-0033
011-E-0011A/B
011-E-0041
011-E-0034
011-E-0023
011-E-0003A/B/C/D
ITEMS
011-E-0012A/B
011-E-0004A/B
011-E-0013
011-E-0005
011-E-0014A/B/C
011-E-0006
011-E-0014D/E/F
011-E-0007A/B/C/D
011-E-0015A/B
011-E-0008
011-E-0016A/B
011-E-0009A/B
011-E-0017A/B
011-E-0044A/B
011-E-0018A/B/C/D 011-E-0019A/B/C 011-E-0019D/E/F 011-E-0020A/B/C 011-E-0020D/E/F 011-E-0045A/B 011-E-0046A/B
SUBSYSTEM J0110209
J0110302
J0110303
J0110304
011-E-0021
011-E-0031A/B
011-E-0030A/B
011-E-0029
011-E-0047A/B ITEMS
J0110305
J011UZ00
011-E-0025A/B/C/D 011-E-0037A/B/C/D 011-E-0026 011-E-0027 011-E-0028 011-E-0036 011-E-0043
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 105 of 244
PRECOMMISSIONING CHECK LIST MECHANICAL FAN & BLOWER P01
*J10022227* *J10022227* ONSHORE
ESTIMATED TIME (MH) :
0,4
EXPENDED TIME (MH) :
Subsystem J0110201 ITEM
CHECK LIST
1
Check that the nameplate details are correct and complete
2
Check that the coupling is level.
3
Check that the holding down arrangements are correct.
4
Check for any installation damage.
5
Check the coupling is installed as per specifications and approved drawings.
6
Check the coupling for cleanliness.
7
Check preservation is carried out as per approved procedure.
8
Check the painted surfaces visualy for any damage.
9
Check the earthing and bonding are as per the Project Specifications.
10
Check the shaft and axial are freely rotating and within the acceptable limit.
11
Check the free operation of dampers and bearings are properly lubricated.
12
Check the start fan in accordance with the manufacturer instruction.
13
Check that the input and output shaft couplings have been installed and also that their guards are in position.
14
Check that all bolts have been re-tightened after the inspection.
15
Produce a set of marked-up drawings in accordance with the installation.
16
Produce a defects list for inclusion in the Punch List issue.
REMARKS:
PUNCH LIST ITEMS
J10022227
CGX11 - FAN & BLOWER
TASK LOCATION :
Item : 011-K-0002-A
FORM :
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 106 of 244
SAME CHECK LIST SHEETS WILL BE USED FOR THE FOLLOWING ITEMS:
SUBSYSTEM J0110201
J0110305
011-K-0002A/B/C
011-K-0004A/B
011-K-0003
011-K-0005
ITEMS
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 107 of 244
PRECOMMISSIONING CHECK LIST MECHANICAL AGITATOR & MIXER P01
*J10022483* *J10022483* FORM :
0,5
EXPENDED TIME (MH) :
Subsystem J011UA11 ITEM
CHECK LIST
1
Check that the nameplate details are correct and complete.
2
Check the location, elevation, orientation and that the shaft is vertical.
3
Check that the holding down arrangements are correct.
4
Check that there is not any installation damage.
5
Check the equipment has been installed as per specifications and approved drawings.
6
Check the equipment for cleanliness.
7
Check preservation has been carried out as per approved procedure.
8
Check the painted surfaces visualy for any damage.
9
Check the equipment is bonded as per specifications and drawings.
10
Check for free rotation of the shaft in the correct direction. Also check the rotor for concentricity and that it does not foul the tank internals.
11
Check that there is adequate space around the unit to withdraw the agitator using suitable lifting gear.
12
Check that the bolting has been suitably lubricated.
13
Produce a set of marked-up drawings which are as per installation.
14
Produce a defects list for incusion in the Punch List.
REMARKS:
PUNCH LIST ITEMS
J10022483
ONSHORE
ESTIMATED TIME (MH) :
Item : 011-K-0005
CHX03 - AGITATOR & MIXER
TASK LOCATION :
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 108 of 244
PRECOMMISSIONING CHECK LIST MECHANICAL RECIPROCATING PUMP P01
*J40003807* *J40003807*
Subsystem J011UA11 ITEM
CHECK LIST
1
Ch eck th at th e n ameplate data is bo th correct an d complete.
2
Ch eck th e location, elevation an d o rientation o f th e p ump an d th at it is level.
3
Ch eck th at th e h olding d own arrangements, fo r th e reciprocating p ump p lus mo tor an d baseplate, are correct.
4
Ch eck fo r any installation d amage.
5
Ch eck th at th e installation o f th e p ump, g earbox, coupling and baseplate is in accordance with th e ap proved d rawings an d specifications.
6
Ch eck th at all the n ozzles which are n ot in use are suitably sealed.
7
Ch eck th e p ump, g earbox, coupling an d the baseplate fo r cleanliness.
8
Ch eck th at p reservation h as been carried o ut in accordance with th e ap p roved p rocedure.
9
Ch eck fo r th e g eneral accessibility o f th e unit and fo r th e p ossibility o f its even tual remo val fo r maintenance.
10
Ch eck visually th e p ainted surfaces fo r d amage.
11
Ch eck th at th e earthing an d bo nding are in accordance with th e Project Sp ecifications.
12
Ch eck th at th e suction and d ischarge pipe supports are in accordance with th e d esign.
13
Ch eck th at th e co upling alignment h as been carried o ut an d record th e fig ures. (where applicable)
14
Ch eck th at bo th th e temp orary fin e mesh filter an d the jo b strainer h ave n o t been d amaged.
15
Ch eck th at th e stuffing-box p acking is un damaged and is in accordance with its sp ecification.
16
Ch eck fo r th e free ro tation o f th e shaft.
17
Ch eck th at all o f th e bearings, incuding th e motor bearings, are correctly lubricated.
18
Ch eck th at th e p ulsation d amper is in accordance with the sp ecifications.
19
Ch eck th at bo th th e coupling an d its coupling g uard have been in stalled.
20
Ch eck th at th e n ozzles are blanked-off if th eir p iping has n ot been in stalled.
21
Pro d uce a set o f marked-up d rawings wh ich are in accordance with th e in stallation.
22
Pro d uce a d efects list.
23
Co n solidate th e abo ve list fo r the Pun ch List issue.
REM ARKS:
PUNCH LIST ITEMS
J10022481
0,5
EXPENDED TIME (MH) :
Item: 011-G-0037-B
ONSHORE
ESTIMATED TIME (MH) :
J10022479
CGX01 - RECIPROCATING PUM PS
TASK LOCATION :
Item: 011-G-0037-A
FORM :
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 109 of 244
SAME CHECK LIST SHEETS WILL BE USED FOR THE FOLLOWING ITEMS:
SUBSYSTEM
ITEMS
J011UA11
J011UA12
J011UA13
J011UA14
011-G-0037A/B
011-G-0030A/B
011-G-0035A/B
011-G-0032A/B
011-G-0031A/B
011-G-0036A/B
011-G-0033A/B 011-G-0034A/B
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 110 of 244
PRECOMMISSIONING CHECK LIST MECHANICAL VERTICAL CENTRIFUGAL PUMP P01
*J10022473* *J10022473* FORM :
0,5
EXPENDED TIME (MH) :
Subsystem J011SA00 ITEM
CHECK LIST
1
Check that the nameplate data is both complete and correct.
2
Check the caisson is installed within the limits recomended for its vertical positioning
3
Check the free rotation of the pump shaft.
4
Check that the motor shaft rotates freely
5
Check the inlet strainer is correctly installed and it is clean and undamaged.
6
Check that all of the rising main sections have been installed using the correct bolting and gaskets.
7
Check that the centering brackets have been correctly installed.
8
Check that the discharge head is correctly bolted.
9
Produce a set of marked-up drawings in accordance with the installation.
10
Produce a defects list for inclusion in the Punch List issue.
REMARKS:
PUNCH LIST ITEMS
J10022473
ONSHORE
ESTIMATED TIME (MH) :
Item : 011-G-0025-A
CGX02 - VERTICAL CENTRIFUGAL PUMPS
TASK LOCATION :
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 111 of 244
PRECOMMISSIONING CHECK LIST MECHANICAL CENTRIFUGAL PUMP P01 - (HOIZONTAL/VERTICAL IN LINE/CAN)
*J40003823* *J40003823*
Subsystem J0110101 ITEM
CHECK LIST
1
Check that the nameplate data is both complete and corrrect.
2
Check the location, elevation and the orientation and also the pump is level.
3
Check the pump, the motor and the baseplate holding down arrangements are correct and secure.
4
Check for any installation damage.
5
Check that the pump, coupling, baseplate and the auxiliary piping are installed in accordance with the specifications and the approved
6
Check the pump, driver, coupling and baseplate for cleanliness.
7
Check preservation is carried out as per approved procedure.
8
Where applicable, check that installation of the platforming and ladders is in accordance with the approved drawings.
9
Check both the painting and insulation for damage.
10
Check the earthing and bonding are as per Project Specifications.
11
Check the suction and discharge pipe-supports are as per design drawings.
12
Check that there is correct alignment between flanges when the suction and discharge pipework is unbolted.
13
Check that the strainer with the finer-mesh is installed.
14
Check the free rotation of the shaft line.
15
Check that there is adequate space around the unit to withdraw the internals with suitable lifting equipment.
16
Check that the coupling and the coupling guards have been installed.
17
Produce a set of marked-up drawings in accordance with the installation.
18
Produce a defects list for inclusion in the Punch List issue.
REMARKS:
PUNCH LIST ITEMS
J10022084
0,5
EXPENDED TIME (MH) :
Item : 011-G-0001-B
ONSHORE
ESTIMATED TIME (MH) :
J10022082
CGX03 - CENTRIFUGAL PUMPS
TASK LOCATION :
Item : 011-G-0001-A
FORM :
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 112 of 244
SAME CHECK LIST SHEETS WILL BE USED FOR THE FOLLOWING ITEMS:
SUBSYSTEM J0110101
J0110102
J0110103
J0110202
J0110203
J0110204
J0110205
011-G-0001A/B
011-G-0024A/B
011-G-0002A/B
011-G-0014A/B
011-G-0013A/B
011-G-0011A/B
011-G-0009A/B
ITEMS
011-G-0003A/B 011-G-0004A/B
SUBSYSTEM J0110206
J0110207
J0110208
J0110209
J0110302
J0110303
J0110304
011-G-0012A/B
011-G-0010A/B
011-G-0008A/B
011-G-0005A/B
011-G-0018A/B
011-G-0016A/B
011-G-0015A/B
ITEMS 011-G-0007A/B
011-G-0017A/B
SUBSYSTEM J0110305
J0110306
J011SA00
J011UL20
J011UM00
J011UW00
J011UZ00
011-G-0029A/B
011-G-0023A/B
011-G-0025B
011-G-0028A/B
011-G-0021A/B
011-G-0006A/B
011-G-0020A/B
011-G-0022A/B
011-G-0019A/B
011-G-0026A/B
ITEMS 011-G-0027A/B
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 113 of 244
PRECOMMISSIONING CHECK LIST MECHANICAL ROTARY PUMP P01
*J40003879* *J40003879*
Subsystem J0110101 ITEM
CHECK LIST
1
Check that the nameplate data is correct and complete.
2
Check the location, elevetion and orientation of the pump and it is level.
3
Check that the holding arrangement, of the rotary pump, motor and baseplate, is secure and correct.
4
Check for any installation damage.
5
Check the installation of the pump, coupling and baseplate is in accordance with specifications and approved drawings
6
Check the pump, coupling and baseplate for cleanliness.
7
Check preservation is carried out as per approved procedure.
8
Check the general accessibility of the unit.
9
Check the painting visualy for damage.
10
Check the earthing and bonding are in compliance with Project Specifications.
11
Check the supports of the suction and discharge pipes are as per
12
Check that the temporary strainer has been installed. Note that it has a finer mesh than the normal job strainer.
13
Check for the free rotation of the shaft.
14
Check there is adequate space around the unit to be able to withdraw the internals.
15
Check that both the coupling and coupling guard have been installed.
16
Produce a set of marked-up drawings in accordance with the installation.
17
Produce a defects list for inclusion in the Punch List issue.
REMARKS:
PUNCH LIST ITEMS
J10022088
0,5
EXPENDED TIME (MH) :
Item : 011-G-0038-B
ONSHORE
ESTIMATED TIME (MH) :
J10022086
CGX08 - ROTARY PUMPS
TASK LOCATION :
Item : 011-G-0038-A
FORM :
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 114 of 244
SAME CHECK LIST SHEETS WILL BE USED FOR THE FOLLOWING ITEMS:
SUBSYSTEM J0110101
J0110103
J0110201
J0110303
011-G-0038A/B
011-G-0039A/B
011-G-0042A/B
011-G-0041A/B
ITEMS 011-G-0040A/B
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 115 of 244
PRECOMMISSIONING CHECK LIST ELECTRICAL HEATERS P01
*J10013912* *J10013912* FORM :
1
EXPENDED TIME (MH) :
Subsystem J0110101 ITEM
CHECK LIST
1
Check equipment is de-energized and safe.
2
Check nameplate data is correct.
3 4
Check cable glands and terminals for proper size and installation. Check equipment tagging against drawings.
5
Check earthing and bonding against drawings.
8
Produce marked-up termination drawing in accordance with installation. Check the avaibility of certification documents according hazardous area equipment installation Check Supplier's documentation and drawings
9
Produce a defects list for punch list issue
6 7
J10013912
ONSHORE
ESTIMATED TIME (MH) :
Item : 011-F-0004
CPX20 - HEATERS
TASK LOCATION :
10 11 12 13 N.A Not Applicable Drawings & doc. ref.:
REMARKS
X
Checked & not accepted
9
Checked & accepted
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 116 of 244
SAME CHECK LIST SHEETS WILL BE USED FOR THE FOLLOWING ITEMS:
SUBSYSTEM J0110101
J0110103
J0110201
J0110303
J0110305
011-F-0004
011-F-0005
011-F-0008
011-F-0007
011-F-0003
ITEMS 011-F-0006
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 117 of 244
PRECOMMISSIONING CHECK LIST PIPING & VESSEL PRESSURE VESSEL P01
*J40003693* *J40003693* FORM :
ITEM
CHECK LIST
1
Check that the nameplate details are both correct and complete.
2
Check location, elevation, orientation and that the vessel is level.
3
Check that the holding arrangements are correct.
4
Check for any installation damage.
5
Check the nozzles are suitably isolated to enable a safe internal examination.
6
Check that the vessel and its internals are in accordance with the approved drawings.
7
Check the vessel internally for cleanliness.
8
Check that all the internal bolting is correctly tightened.
9
Check preservation is carried out as per approved procedure.
10
Check that all the platforming and ladders are installed in accordance with the approved drawings. Also check that the manways are accessible and suitable for use.
11
Check all painting / insulation / internal linings for damage.
12
Check the earthing and bonding is as per project specification.
13
Check that the vessel pipe supports are in accordance with the design.
14
Check that with disconnected pipework that the pipe flanges correctly align with the nozzle flanges.
15
Check that the internal components can be withdrawn with the aid of suitably installed lifting equipment.
16
Check that the bolting is suitably lubricated.
17
Produce a set of marked-up drawings in accordance with the installation.
18
Produce a defects list for inclusion in the issued Punch List.
REMARKS:
PUNCH LIST ITEMS
J10022098
Subsystem J0110102
Item : 011-D-0002
0,6
EXPENDED TIME (MH) :
J10022096
ONSHORE
ESTIMATED TIME (MH) :
Item : 011-D-0001
CCX01 - PRESSURE VESSEL
TASK LOCATION :
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 118 of 244
SAME CHECK LIST SHEETS WILL BE USED FOR THE FOLLOWING ITEMS:
SUBSYSTEM J0110102
J0110103
J0110202
J0110203
J0110204
J0110205
J0110209
J0110302
011-D-0001
011-C-0001
011-C-0002
011-C-0006
011-C-0005
011-C-0004
011-D-0004
011-C-0003
011-D-0002
011-D-0003
ITEMS 011-D-0005
SUBSYSTEM J0110305
J0110306
J011SA00
J011UA11
J011UA12
J011UA13
J011UA14
011-D-0009
011-C-0007
011-D-0014
011-D-0034
011-D-0031
011-D-0033
011-D-0032
011-D-0016
011-D-0025
011-D-0017 ITEMS 011-D-0028 011-D-0029 011-D-0030
SUBSYSTEM J011UD00
J011UL30
J011UM00
J011UN20
J011UN30
J011UW00
J011UZ00
011-D-0015
011-D-0026
011-D-0007
011-D-0019
011-D-0012
011-D-0006
011-D-0018
011-D-0010
011-D-0020
011-D-0021
011-D-0008
011-D-0011
011-D-0024
011-D-0022
ITEMS 011-D-0013
011-D-0023
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 119 of 244
TEST SHEETS
PRECOMMISSIONING TEST SHEET MECHANICAL HEAT EXCHANGERS P01
*J10022045* *J10022045* FORM :
Item : 011-E-0001
TMX02 - HEAT EXCHANGERS
FRESH CRUDE / KERO Dw g N° :
SA-JER-DS011-TRJR-480003
TASK NUMBER :
TASK LOCATION :
J10022045
ESTIMATED TIME (MH) :
ONSHORE
EXPENDED TIME (MH) :
3,2
Subsystem J0110101
T
PUNCH LIST ITEMS :
DATAS
Datasheet : TUBE BUNDLE DESIGN PRESSSURE
Barg
TEST PRESSURE
Barg
SHELL
TEST MEDIUM
TEST RESULTS
TUBE BUNDLE DURATION OF TEST
mins
TEST PRESSURE - START
Barg
TEST PRESSURE - FINISH
Barg
TEST MEDIUM TEMPERATURE
TE
REMARKS
°C
SHELL
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 120 of 244
SAME CHECK LIST SHEETS WILL BE USED FOR THE FOLLOWING ITEMS:
SUBSYSTEM J0110101
J0110102
J0110103
J0110201
J0110203
J0110204
J0110205
011-E-0001
011-E-0032A/B
011-E-0010A/B
011-E-0040
011-E-0035
011-E-0024
011-E-0022
011-E-0002
011-E-0033
011-E-0011A/B
011-E-0041
011-E-0034
011-E-0023
011-E-0003A/B/C/D
ITEMS
011-E-0012A/B
011-E-0004A/B
011-E-0013
011-E-0005
011-E-0014A/B/C
011-E-0006
011-E-0014D/E/F
011-E-0007A/B/C/D
011-E-0015A/B
011-E-0008
011-E-0016A/B
011-E-0009A/B
011-E-0017A/B
011-E-0044A/B
011-E-0018A/B/C/D 011-E-0019A/B/C 011-E-0019D/E/F 011-E-0020A/B/C 011-E-0020D/E/F 011-E-0045A/B 011-E-0046A/B
SUBSYSTEM J0110209
J0110302
J0110303
J0110304
011-E-0021
011-E-0031A/B
011-E-0030A/B
011-E-0029
011-E-0047A/B ITEMS
J0110305
J011UZ00
011-E-0025A/B/C/D 011-E-0037A/B/C/D 011-E-0026 011-E-0027 011-E-0028 011-E-0036 011-E-0043
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 121 of 244
PRECOMMISSIONING TEST SHEET MECHANICAL MACHINERY ALIGNMENT P01
*J10022083* *J10022083* FORM :
Item : 011-G-0001-A
TMX08 - MACHINERY ALIGNMENT
CRUDE CHARGE PUMP A Dw g N° :
SA-JER-DS011-TRJR-480002
TASK NUMBER :
TASK LOCATION :
J10022083
ESTIMATED TIME (MH) :
ONSHORE
EXPENDED TIME (MH) :
3,5
Subsystem J0110101
T
PUNCH LIST ITEMS :
D AT A Datasheet DRIVEN EQUIPMENT
EQUIPMENT N°
DRIVER EQUIPMENT
EQUIPMENT N°
COUPLING TYPE
SIZE
COUPLING MANUFACTURER
MACHINE CONDITIONS BASEPLATE HOLDING DOWN BOLTS PIPING FLANGE BOLTS
LOOSE
TIGHT
LOOSE
TIGHT
ALIGNMENT RESULTS COLD ALIGNMENT
PERMISSABLE
RECORDED VALUES
1
ANGLE
0°
90°
2
VIEWED FROM DRIVER,
2
180°
RUNOUT CONCENTRIC
PARALLEL NOTES :
3
u or mm
R1
u or mm
A1
R2
1 CHECK VENDORS OPER. MANUAL, 3
ROTATION OF BOTH COUPLINGS
R 0
DRIVEN
DRIVER
A1 270
90
R2 GAUGES POSITIONS
T
REMARKS
180 ORIENTATION FROM VIEWER
270°
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 122 of 244
SAME CHECK LIST SHEETS WILL BE USED FOR THE FOLLOWING ITEMS:
SUBSYSTEM J0110101
J0110102
J0110103
J0110201
J0110202
J0110203
J0110204
J0110205
011-G-0001A/B
011-G-0024A/B
011-G-0002A/B
011-G-0042A/B
011-G-0014A/B
011-G-0013A/B
011-G-0011A/B
011-G-0009A/B
011-G-0038A/B
011-G-0003A/B
ITEMS
011-G-0004A/B 011-G-0039A/B 011-G-0040A/B
SUBSYSTEM J0110206
J0110207
J0110208
J0110209
J0110302
J0110303
J0110304
011-G-0012A/B
011-G-0010A/B
011-G-0008A/B
011-G-0005A/B
011-G-0018A/B
011-G-0016A/B
011-G-0015A/B
ITEMS
011-G-0007A/B
011-G-0017A/B 011-G-0041A/B
SUBSYSTEM J0110305
J0110306
J011SA00
J011UA11
J011UA12
J011UA13
J011UA14
011-G-0029A/B
011-G-0023A/B
011-G-0025B
011-G-0037A/B
011-G-0030A/B
011-G-0035A/B
011-G-0032A/B
011-G-0031A/B
011-G-0036A/B
011-G-0033A/B
ITEMS
011-G-0027A/B
011-G-0034A/B
SUBSYSTEM J011UL20
J011UM00
J011UW00
J011UZ00
011-G-0028A/B
011-G-0021A/B
011-G-0006A/B
011-G-0020A/B
011-G-0022A/B
011-G-0019A/B
011-G-0026A/B
ITEMS
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 123 of 244
PRECOMMISSIONING TEST SHEET MECHANICAL GENERAL PURPOSE P01
*J10022222* *J10022222* FORM :
Item : 011-F-0001
TMX00 - GENERAL PURPOSE
CRUDE HEATER Dw g N° :
SA-JER-DS011-TRJR-480117
TASK NUMBER :
J10022222
ESTIMATED TIME (MH) :
TASK LOCATION :
ONSHORE
EXPENDED TIME (MH) :
Subsystem J0110201
T
PUNCH LIST ITEMS :
0,1
TEST RESULTS
SKETCHES / NOTES
TE
REMARKS
SAME CHECK LIST SHEETS WILL BE USED FOR THE FOLLOWING ITEMS: 011-F-0001 and 011-F-0002
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 124 of 244
PRECOMMISSIONING TEST SHEET ELECTRICAL ELECTRICAL HEATERS P01
*J10013913* *J10013913* FORM :
Item : 011-F-0004
TPX20 - ELECTRICAL HEATERS
LUBE OIL HEATER FOR PUMPS 011-G-0001-A/B Dw g N° : TASK NUMBER :
TASK LOCATION :
J10013913
ESTIMATED TIME (MH) :
ONSHORE
EXPENDED TIME (MH) :
1
Subsystem J0110101
PUNCH LIST ITEMS :
NAME PLATE DATA MANUFACTURER :
A RATING:
VOLTAGE :
V
FREQUENCY :
Hz IP RATING:
SUPPLIED FROM :
TYPE:
SERIAL N° : FLC :
KW
DATA SHEET: SPECIFICATION:
type of protection:
TESTING INSTRUMENTS USED TYPE / SERIAL N° :
TYPE / SERIAL N° :
TYPE / SERIAL N° :
TEST RESULTS INSULATION RESISTANCE TEST
Volts
TEST VOLTAGE : R/ S-T-EARTH
Mohm S/ R-T-EARTH
Mohm T/S-R-EARTH
Mohm
RESISTANCE MEASUREMENT R1 - R2
REMARKS
Ohm S1 - S2
Ohm T1 - T2
Ohm
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 125 of 244
SAME CHECK LIST SHEETS WILL BE USED FOR THE FOLLOWING ITEMS:
SUBSYSTEM J0110101
J0110103
J0110201
J0110303
J0110305
011-F-0004
011-F-0005
011-F-0008
011-F-0007
011-F-0003
ITEMS 011-F-0006
PRECOMMISSIONING TEST SHEET MECHANICAL VESSELS AND TANKS P01
*J10022097* *J10022097* FORM :
Item : 011-D-0001
TMX01 - VESSEL / TANKS
DESALTER 1ST STAGE Dw g N° :
SA-JER-DS011-TRJR-480011
TASK NUMBER :
J10022097
ESTIMATED TIME (MH) :
3,2
Subsystem J0110102 TEST RESULTS
DURATION OF TEST
mins
TEST PRESSURE - START
Barg
TEST PRESSURE - FINISH
Barg
TEST MEDIUM TEMPERATURE
°C
T
REMARKS
ONSHORE
EXPENDED TIME (MH) :
T
PUNCH LIST ITEMS :
TASK LOCATION :
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 126 of 244
SAME CHECK LIST SHEETS WILL BE USED FOR THE FOLLOWING ITEMS:
SUBSYSTEM J0110102
J0110103
J0110202
J0110203
J0110204
J0110205
J0110209
J0110302
011-D-0001
011-C-0001
011-C-0002
011-C-0006
011-C-0005
011-C-0004
011-D-0004
011-C-0003
011-D-0002
011-D-0003
ITEMS 011-D-0005
SUBSYSTEM J0110305
J0110306
J011SA00
J011UA11
J011UA12
J011UA13
J011UA14
011-D-0009
011-C-0007
011-D-0014
011-D-0034
011-D-0031
011-D-0033
011-D-0032
011-D-0016
011-D-0025
011-D-0017 ITEMS 011-D-0028 011-D-0029 011-D-0030
SUBSYSTEM J011UD00
J011UL30
J011UM00
J011UN20
J011UN30
J011UW00
J011UZ00
011-D-0015
011-D-0026
011-D-0007
011-D-0019
011-D-0012
011-D-0006
011-D-0018
011-D-0010
011-D-0020
011-D-0021
011-D-0008
011-D-0011
011-D-0024
011-D-0022
ITEMS 011-D-0013
011-D-0023
IV.3. Cleaning of Piping and Equipment This paragraph gives a list of methods of cleaning to be used for removing foreign materials in piping and equipment.
IV.3.1. Water Flushing
The objective of water flushing is to eliminate all foreign materials that may be introduced into lines and equipment during their transportation, storage and erection. Water flushing can be applied to the following pipes and equipment:
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 127 of 244
•
Process lines which normal operating flow are liquid phase fluids and where small water traces is not a problem for process, when these lines will be dried out after water flushing.
•
Process lines of small diameter where normal operating flow are gases and where small water traces is not a problem for process, when these lines will be dried out after water flushing.
•
Lines where water is the normal fluid (raw water, plant water, process water, cooling water, tempered water, boiler feed water, demineralised water, etc.).
•
Drain lines.
•
Lines which normal operating fluid is a chemical compatible with small water traces.
•
Equipment requiring water flushing.
Cleaning operation must be carried out following the hereafter recommendations: •
Identify loop and prepare same for cleaning, e.g. install blind discs, temporary connections, etc.
•
Disconnected pump turbine, compressor intake and discharge lines and cover casing nozzle to prevent cleaning medium from entering.
•
Remove orifice plate.
•
Remove or blank or bypass control valve and safety.
•
Blank and protect instrument connections.
•
Do not flush into lines connected to equipments, vessels and heat exchanger; disconnected joints and cover flanges; after sufficient flushing, reconnect lines and flush water through equipment, vessels and exchangers to next section of line.
•
Open overhead vents vessels to prevent vacuum effects.
The following precautions must be paid when water flushing is carried out: 1. Water used for flushing must be clean and fresh. (Sea water is prohibited in systems other than sea water networks).
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 128 of 244
2. All piping systems will be flushed using high pressure (60.8 mPa (8.8.ksi) minimum) jet such as rotating hose or rotating nozzle. 3. Below 4”, High Velocity Water Flushing (HVWF). On systems where high pressure jet flushing cannot be used due to complicated shapes and/or long runs HVWF or slug flushing. 4. Velocity used in flushing will be a minimum of 3 m/sec. Duration will be decided according to water cleanliness at the exit point. 5. A maximum allowable chloride concentration shall be less than 50 ppm for pipes made of austenitic stainless steel to avoid stress corrosion crack. The final rinsing will be carried out with inhibited water. NO3Na will be added to the water three times the chloride ion content. After all the operations, the piping systems will be completely drained, dried to a dew point below -1ºC and protected against corrosion. 6. Suitable measures will be taken to ensure that dirty water does not go inside equipment. 7. The suction side of a pump must be equipped with a strainer to catch foreign materials. For strainers, 20 mesh temporary screens are normally recommended but each pump will be assessed individually by Comm. Team. 8. Provision of an air connection is required to enhance drain out by air sweeping after water flushing for oil handling lines. 9. After water flushing lines will be air dried using air from plant air system connected by hoses to suitable points, as required. 10. Equipment which is sensitive to damage during flushing shall be removed, blocked off or isolated. A list will be prepared and be part of the flushing procedure. Ball valves shall be flushed in fully open position. 11. Mechanical completion shall be done immediately after the flushing if there will be no additional work on the line, e.g. steam blowing. This method is recommended for: 1. Cooling water system 2. Condensate system 3. Potable water
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 129 of 244
4. Service water
IV.3.2. Steam Blowing
As soon as the steam headers and lines have been hydro tested they are ready for blowing. The order of blowing is as follows: •
Main supply header
•
Unit sub header
•
Individual branch lines
Where required temporary vent lines will be installed deflecting the steam safely to atmosphere. This will mainly be at battery limits and on individual steam supplied equipment. Target mounting methods must ensure that the targets will remain safely attached during the steam blowing process. Actual target materials shall be polished 304 or 316 stainless steel. At least two targets shall be supplied to the test. All drain points on the line to be blown should be full open to avoid scale accumulation during the blowing. All steam traps on the system should be isolated with the drain lines open and/or by pass lines open. Orifice plate tappings should be open to drain. Initially steam will be slowly introduced into the system to allow a steady temperature rise in the piping and equipment. Condensate must be drained from all low points to avoid producing water slugs which could be vaporized, raising the pressure and causing hydraulic shock and possible damage in the gaskets and pipes. IV.3.2.1. Precautions The following precautions must be taken when steam blowing is conducted.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 130 of 244
1. Before conducting steam blowing, the following matters must be notified to the boiler unit to prevent that the balance of steam demand and supply is lost due to large consumption for steam blowing. •
Initial review and discussion of the work
•
Steam Blowing Schedule
•
Approximate Steam Consumption
•
Daily meeting during the job and reschedule if needed
2. Steam blowing generates noise and thereby is liable to interfere with other work. It is necessary, therefore, to take appropriate measures. In particular, temporary silencers will be installed in the steam exhaust to atmosphere. 3. Steam shall be blown out towards the safe side at steam discharge points. A temporary elbow or vent line must be installed if possible at blow-off end when a free space of approximately 5 meters is not available to permit safe blowing. 4. A safety barricade and warning signs shall be stretched approximately 10 m. around the blow-off end to prevent people from coming into the dangerous area. 5. Any combustible material shall be removed from pipes before steam blowing. 6. Before conducting steam blowing, it is required to warm up the pipe concerned to prevent hammering due to steam condensation. This warming up must be carried out until steam exits from the pipe vent. 7. In order to achieve affective steam blowing, blowing and cooling cycles will have to be repeated several times depending on service. 8. When the steam line is in the cool-down step, the blow-off end must be kept open to prevent vacuum formation inside the pipe. 9. The steam line, where steam blowing has been completed and reinstated, shall be placed in service with steam as soon as possible. 10. During steam blowing, it is essential that the people in charge of the actual blowing should keep their position at all times. These people must have a radio communications in case of emergency to stop blowing. Continuous monitoring of lines under steam blowing shall be ensured looking for any unusual expansion of any part of the pipe or any abnormal situations.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 131 of 244
11. Blowing valve operations normally are followed by minimum of 2 operators maintaining radio communication with each other and the utilities also concerned.
IV.3.2.2. Quality Considerations and Acceptance Criteria Acceptance criteria for steam blowing also differ depending on the properties of steam users. Lines Equipped with a Target Plate (only for High Pressure Steam, 64 barg) A target plate shall be brought into contact with blow-out steam at right angles and the number and impacts formed on the plate due to the impact of foreign materials shall be observed. Acceptance criteria for these lines shall be specified as follows: •
It will have no raised pit
•
The number of impacts usually observed shall not exceed three per square centimeter.
•
The size of an impact shall not exceed 0,5 mm.
Lines Where Rated Program Will Be Applied Steam blowing is deemed complete when no dirt or debris is witnessed at the blow-off point. Lines Where Once Steaming Will Be Applied Steam blowing is deemed complete when once steaming has been smoothly carried out, using the correct flow and time factors. This method is recommended for: 1. Boiler feed water system 2. Steam lines
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 132 of 244
3. Furnace piping (as convection and radiant section if refractory lined pipes are not installed)
IV.3.3. Air blowing
Air-Blowing is one of the most efficient methods of cleaning piping systems. In this technique a large-volume, clean system is selected as an air reservoir (a vessel) and used to store dry air which is then released into smaller open-ended piping systems where the velocity will significantly exceed the normal operational velocity thus resulting in debris removal. The objective of air blowing is to eliminate all foreign materials that may be introduced into lines and equipment during their transportation, storage and erection. Air blowing shall be applied to the pipes which have not been hydraulically tested or where water flushing is not considered practical or necessary, e.g. air compressor discharge lines, compressors lube oil pipes, etc. During the cleaning operation, the air velocity shall be as follows: •
Pneumatic flushing with dry air (Dew point -1ºC or less) or steam with a minimum exit velocity of 15 m/s. Repeat flushing until cleanliness is verified by observing the absence of any solids impact on a polished metal target at the exit.
Air blowing shall be applied to the following pipes: •
Chemical Lines.
•
Inst/Plant Air Line.
•
Hydrogen Line.
•
Nitrogen Line.
•
Fuel Gas Line.
•
Combustion Air Line.
•
Cold Service Line.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 133 of 244
•
Catalyst tubes and pigtails.
Air blowing, however, may not be limited to only the above, but may be applied also to other service lines following water flushing or process lines with a diameter bigger than 14 inches. Air blowing utilizes kinetic energy of air flow. In air blowing, however, high velocity must be expected to obtain large kinetic energy since the specific gravity of air is much smaller than water. This system of cleaning is used on parts of the plant where it is necessary to keep the pipe work dry. All the guidelines applied to water flushing apply equally on air, in that it should be preplanned so that dirt and debris does not accumulate in demisters, vessels, etc. Air blowing also serves the purpose of removing free water from the piping. In air blowing pipe work, the objective is to maintain a high air velocity through the line for an extended period. To achieve this it is normal to include some large volume vessel (reactor, column, etc.) in the circuit to be blown. The circuit is then pressured up with air, and then rapidly vented out at an open end with the vessel in the circuit acting as an air reservoir to sustain the blow over a longer period. Utility air or air generated by temporary compressor can be used as an air source for blowing. The normal air compressors may be used for blowing out the relative pipe work. The following precautions must be taken when blowing out is conducted 1. Instrument air must be used to blow out instrument air system and nitrogen pipes. 2. Mechanical run in of the compressor or blower shall be completed before pipes concerned by blowing. When starting the compressor or blower, the Vendor’s manual must be referred to. 3. Air flushing is a hazardous Operation, as very high forces are generated at the air outlet. Therefore, specific safety procedures must be closely adhered to, generally air flushing operations will be undertaken when all other works have been stopped on site. 4. Generally air blowing will take place after normal working hours.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 134 of 244
5. An area of least 30 meters around the outlet points will be roped off during the release of air. 6. A check list should be filled before start the air blowing. 7. Mechanical completion shall be done immediately after the flushing.
IV.3.4. Oil Flushing
The reliable operation of controls and machine bearings is dependent upon the cleanliness of the lubricating oil system. Even if the best care has been taken in fabricating and erecting the oil system to maintain cleanliness, some contamination will unavoidably be introduced into the system. Therefore an oil flush must be performed on all lube oil systems before start up to keep the contamination to an absolute minimum. Oil Flushing is generally performed prior to initial commissioning as well as following shutdown maintenance on hydraulic lube oil and seal oil systems. This will ensure that the system is free of any foreign contamination therefore prolonging service life and reducing un-planned and costly down time. Systems such as fuel lines lube lines on dynamic equipment such as compressors or turbines, oil transfer lines and hydraulic systems require oil flushing due to the extremely clean piping specification. The reuse and/or oil disposal will be according with JER and Saudi Legislation. Necessary instructions for cleaning the lube and seal oil piping systems are given in Manufacturer’s documents. They shall be strictly followed. IV.3.4.1. Method Before commencing oil flushing, the lube oil and seal oil piping systems will be blown with air in order to remove all dirt and debris. Blowing will be performed jointly with hammering of piping for removal of mill scales. Air blowing will also remove water or moisture present into the piping system. Prior to charging the system with flushing oil it is recommended to confirm the cleanliness of the piping by inspecting all accessible areas.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 135 of 244
A jumper spool should be installed to bypass the machine bearings, seals, couplings and other accessory devices. If it is not practical to flush the feed lines in situ, they are removed, thoroughly cleaned, sealed and stored for the flushing period. Typically the same type of oil used in routine service will be used for flushing, unless otherwise specified by the vendor. Temporary stainless steel screens of a screen mesh defined by the vendor, backed up by perforated steel plates should be installed to the downstream side of the jumpers for collecting dirt that will be freed during the flushing. The amount of dirt, plotted against flushing time will give an indication of the state of cleanliness of the system. Gate shut off valves may be installed at outlet from jumpers so ensuring a higher flushing velocity by sequential isolation of each line. The charge of the oil for flushing the system should be enough to maintain lube oil pumps submerged during operation. Lubricant oil will be circulated into the whole system by using its own lube oil pumps and heated up to 60ºC - 70°C by means of console heater or by a temporary steam connection to the oil coolers if is necessary. It is preferred to circulate the oil with the two lube oil pumps to increase the velocity through the pipes. The oil circulation will be extended to the whole system progressively. After 48 hours of uninterrupted circulation, screen mesh will be installed between flanges on oil return line to the oil tank. Usually screen with 100 meshes are used. The screen will be regularly inspected for cleanliness with a frequency depending on the quantity and nature of dirt found. Throughout the flushing, the oil in the system should be heated and run at a temperature of approx. 70ºC if is necessary. A thermal shock of the system, obtained allowing the oil temperature to drop temporarily to approx. 50ºC, may be found effective for loosening adherent particles which are not readily removed by a continuous flow of hot oil. The dislodgement of particles that may have adhered to the piping surfaces should be accelerated by vibrating or hammering oil lines. IV.3.4.2. Quality Considerations and Acceptance Criteria The success of the operation depends mainly on the capability of the oil pumps to provide a flow rate larger than the normal and thus a high velocity within the lines.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 136 of 244
Flushing should continue until inspection discloses a definitive reduction in size and number of particles collected in the separators, filter elements and screens, and the screens are accepted by the appropriate vendor. When flushing is complete, heating of the oil should be discontinued and circulation continued until the temperature drops to approx. 50ºC at cooler outlet. After a minimum of 24 hours of flushing oil circulation final cleanliness check shall be made, them the inspection screens shall be cleaned and reinstalled and the flushing will be circulated for a period of 12 hours. (When dirt, sand and metal particles are no longer visible on screen mesh installed for inspection the oil flushing shall be deemed satisfactorily completed). Then the oil pump is to be stopped and the system drained via low point drains. The reservoir and filter body should be inspected and all traces of residual contamination removed.
IV.3.5. Chemical Cleaning
The purpose of this work is to remove water scale, grease, deposit oxides, which have been formatted during construction activities so we can ensure an optimum flow as well as an efficient output. This removal will be done using chemical products. The chemical cleaning treatment for each item will depend on the deposit composition, quantity, distribution and may vary considerably between one system to another, or even within the same system at various time periods during its life. Chemical cleaning of process lines shall be applied to all pipes and equipment where defined as necessary this type of cleaning. It shall be applied mainly to carbon steel suction and inter-stage pipes of Reciprocating Compressors (when applicable), external systems circulating lube oil and seal oil for centrifugal compressors, turbo-generators and centrifugal pumps. In general it will be applied to systems where water, or other fluid, used for flushing and cleaning doesn’t assure the elimination of materials which can be adverse for process performance. Materials to be removed are grease, oils, fine solids, free or adhered material and reactive substances with process products.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 137 of 244
IV.3.5.1. Choice of Method Two methods are normally used: •
Static cleaning
•
Circulating cleaning
The static method is useful where only short runs of pipe are concerned and consist merely of filling the pipe, or immersing shot sections in a tank, and leaving it to stand for approximately 10 hours. The circulation method is employed where long awkward pipe runs are encountered and requires a reservoir, a small circulation pump capable of handling mildly corrosive liquids and some lengths of flexible hosing of suitable diameter. The various piping items are bolted up to form a closed loop and the solution is pumped through the loop and recirculated into the reservoir. This method is much more efficient than the static method due to the constant movement of the solution through the pipes. It also allows the simultaneous cleaning of several systems, i.e. the lube and seal oil piping from three identical compressors can be cleaned at the same time. The choice of method is determined by the Sub-Contractor taking into account design specifications for process lines. IV.3.5.2. Sequence of Operations System flushing with water It is performed to achieve mechanical removal of solid materials, to check circulation and to remove leaks. Degreasing All pipe work shall be degreased to remove oil, grease and lubricants, which are insoluble in acid. Degreasing will be achieved by Sub-contractor approved solution.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 138 of 244
The following degreasing solutions are proposed: • Chemical composition of the solution: o Sodium Carbonate Na2CO3: 3 g/l or o Sodium Tripolyphosphate P3O15Na5: 2g/l and trisodium phosphate Na3PO4:1g/l, in either case a suitable wetting agent may be used. •
Duration, about 12 hours.
Intermediate rinsing Following degreasing, the pipework shall be flushed with preferably demineralised water at 70°C for 15 minutes to remove chemical agents and solid materials. Water pH minimum 7.0 Verify removal by monitoring pH of the flushed water. Acid Pickling Pickling by acid is performed to remove mill scale, etc., and shall be achieved by dipping or by circulation using acid inhibited by anticorrosion agent. The nature and concentration of acid and corrosion inhibitor, the temperature of the solution and the duration of operation are determined by the Sub-Contractor in the Specific Procedure. The following pickling chemical composition is proposed: •
Hydrochloric acid.
•
Ammonium Bifluoride.
•
Inhibitor.
During pickling operations, the temperature and pH of the solutions shall be periodically monitored to ensure consistent conformance with the Sub-Contractor procedure.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 139 of 244
The ferric ion (Fe3+) shall be monitored and the acid solution replaced, if it exceeds 0.4% weight. Main rinsing On completion of pickling, the pipework shall be flushed with clean water, monitoring the pH of the flushing water at the outlet. The circulation shall continue for a minimum of 10 minutes after the point at which the inlet and outlet pH are the same. Then the pipework shall be drained of water. Neutralizing and passivating Neutralizing and passivating shall follow immediately after pickling and flushing, and will create a protective coat of Fe304.inside the pipe. The solution used will be 1% of citric acid in water, preferably demineralised but at least potable, with an inhibitor, followed by: •
Neutralization: Add ammonia in order to obtain pH 9 to 9.5.
•
Passivation: Add Na NO2 and recirculate for three hours.
Drying On completion of passivating, pipework systems shall be thoroughly drained and dried by blowing warm nitrogen or with instrument air. Inspection It consists in a visual inspection of each piping item for cleanliness. Pipewalls should have a matt grey appearance. Re- assembly and oil flushing The final step will be to reinstall each piping item using new gaskets according to the VENDORS drawings or specifications. For Lube and seal oil systems, check the cleanliness of the oil reservoir(s), if suspect, manual cleaning using a suitable detergent is required.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 140 of 244
The system may now be filled with the correct grade of lube oil. IV.3.5.3. Chemicals Choice The Sub-Contractor will carry-out the choice of chemicals with the concentration to use for all the different phases of the chemical cleaning. They must fit with the method and the operating conditions determined in the Specific Procedures. The Sub-Contractor will take into account in its choice: 1. The easiness and safety of use of the chemicals. 2. The metal of pipes and equipment in the circuit to be chemical cleaned. 3. Pipes and equipment must not be damaged by the chemical cleaning. Corrosion inhibitor shall be used to prevent attack to the metal. 4. The disposal and treatment of effluents.
IV.3.5.4. Operating Conditions The Sub-Contractor will determine the definition of circuits or parts of circuits in which circulation of solutions for chemical cleaning will be performed, and spool pipes which will be treated by immersing. From this definition of method, the Specific Procedure will include for each operation the operating conditions: 1. Corrosion inhibitor concentration. 2. Temperature. 3. Circulation flow. 4. Chemicals solution concentration. 5. Treatment duration. 6. Quantity of solution. (Ferric ion content shall remain lower than 0.4% weight).
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 141 of 244
IV.3.5.5. Effluents Handling The effluents shall not contaminate ground, sewer or river with solutions beyond that permitted by local Pollution Control Authority. The chemical cleaning Sub-Contractor shall arrange for the effective control, neutralization, disposal and handling of effluents. In no cases, the local regulations for pollution shall be transgressed. If disposal of effluents to a sewer is permitted, it will be done after neutralization and via a disposal tank. IV.3.5.6. Acceptance Criteria The chemically cleaned pipes shall be examined at accessible points. The internal surface of pipe shall be uniform and free of rust and deposits. If the inspections show imperfect treatment, the operations of chemical cleaning shall be started again. During flushing phase, it shall be controlled visually the returned liquid, it must be similar to entering liquid; circulation will be maintained until this moment. Solids and debris will be controlled by temporary filters. Depending on the phase and product used for Chemical Cleaning, the following parameters shall be controlled: turbidity, pH, total iron (Fe3+), conductivity, and other parameters as defined in the Specific Procedure.
IV.4. Specific Pre-Start-up Operations This paragraph describes the activities to be done for preparing the unit for start-up. Commissioning is carried out after approval of Mechanical Completion.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 142 of 244
Commissioning testing verifies readiness for starting up and involves the functional testing of segments of the facilities to confirm that important items are suitably prepared for safe and reliable operation. Commissioning Tests involve simultaneous multidiscipline checks of a string of process equipment, machinery, instruments, vessels, piping and other items, in simulated dynamic operation. Tests may take place over an extensive area of plant. Relatively safe fluids and plant conditions are typically employed, thus facilitating rapid intervention for any corrective activity found to be necessary. Area safety controls may be imposed, including the use of task specific permits to work, rather than generic area work permits used in construction. Commissioning tests provide an appropriate degree of assurance that safe and reliable operations will be achievable in a reasonable period of initial Start-up. The scope and duration of these planned activities is dependent on the type of facility and the severity of its intended operating service. Where processes contain hazardous fluids at high severity during normal operation, a rigorous sequence of commissioning tests will be necessary. The scope of work of the commissioning activities will include the following: •
Functional test o Energize electrical distribution network o Electrical motor runs o Instrument loop test o Telecom System tests
•
Piping and vessel preparation o Leak test at operational pressure o Drying out and inerting o Loading of chemicals and inerting
•
Operational test o Compressor and turbine run-in
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 143 of 244
o Pump and driver run-in Also, refer to procedure 011-IP-0001 CDU/VDU Preparation for Start up, Attachment 32
IV.4.1. Instrument Loop Test
For the instrumentation activation, operational checks shall be performed. For this purpose, clean dry instruments air and electrical power shall be available in the plant. During Commissioning phase Dynamic/Energized tests of each instrumental function and/or Electrical function linked to DCS/ESD, will be performed according to its design criteria. The Loop/Functional Test priorities shall be dictated by the project schedule. Functional tests shall also include package units or mechanical packages supplied by Vendor. Following documented operations, sequential loops checks will be carried out: •
Overall loop continually shall be checked.
•
Individual sequential tests shall be performed on each interlock and emergency system.
•
A simultaneous check of all the system components shall be performed at the various control centers (substations, control room and local panel).
•
The interlock and/or emergency systems shall be checked also for “fail safe” operation, which will include power failure and/or “burnout”, if thermocouples are used.
IV.4.1.1. Loop Test Methodology 1. For loops and signal will be tested with a 4-20 mA. Generator. For ultrasonic, magnetic and mass flow meters not using Hart Protocol, it is not possible to simulate the process side, the vendor datasheets shall be used to verify the parameters.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 144 of 244
2. For Temperature measurement, in a first step, check against the ambient temperature measured with an accurate thermometer and then use of a RTD/thermocouple simulator. 3. For level measurement, test the torque tube on the warehouse, and then testing the line with 4-20 ma generator. 4. For gas detectors: Reference gas samples will be used as per the thresholds selected for the project. 5. For fire detectors, appropriate sources (light, smoke...) will be used. 6. For control valves: •
Check instrument air supply and pressure.
•
Close air supply and confirm fail safe movement.
7. The Operator on the DCS console shall guide the Field Loop Test Team through the checkout, confirming the results at the console and verifying the response of the controller output. These results must be confirmed/accepted by SATORP. DCS operator console will fill-in the ICAPS test sheet with the values read at screen when the test is done. Compliance audit with DCS/ESD scale by simulating three operating points in 2 directions: 0%→50%→100%→50%→0%. 8. The Field Loop Test Team shall confirm the output response along with control valve action and failure mode. 9. Priority will be given to ESD and F&G checks due to complexity and security. 10. For safe guarding systems, an operator interface (PC) shall be set up in the PIB building; this will be manned by a trained Technician or DCS Vendor representative who will follow for “Safety Functions” a step by step “Logic function test”, one of SATORP could witness the tests. 11. Any problems relating to the DCS shall be logged in a punch list folder set up in the control room. Vendor representatives or Instrument Technicians shall resolve the problem; clear the punch list and sign and sign as being completed. When the problem has been cleared the Loop Test Team shall repeat the relevant test to probe the problem has been resolved. 12. The field teams will identify any problems or deficiencies encountered in the field instrumentation on a punch list and pass the punch list to their respective supervisor for resolution. The originator of the punch list shall sign off the items as they are completed.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 145 of 244
13. Once the punch list is solved / cleared, the Loop Test Team must repeat the relevant test. 14. All punch lists shall be prepared in accordance with SATORP Procedures.
IV.4.1.2. Function Test Method for Logic and Sequence Functions 1. Individual loops associated with Complex, Logic Loop or Sequence systems will be initially tested using the specific form and these will be confirmed as being accepted prior to utilising these loops in a more complex system. 2. A “Logic Function Test” must be written before Commissioning Activities and verified by SATORP Acceptance of the Logic Function Test shall be made with the specific form. 3. The Logic Function Test Plan as generated by the Instrument Supervisor shall be used to ensure the checkout is in accordance with the safeguarding, and Control Narrative. 4. The field Function Test Team allocated to the logic function testing shall simulate the process variable by imposing a signal into the process side of the transmitter to produce an electronic output at the DCS, ESD or PLC. The forcing or disabling of the logic to generate a field action or output is not permitted during the testing of logic functions. Output simulators shall only be used where alternative methods are not feasible. This shall have been agreed with SATORP, in advance, as a part of the Function Test Plan review. 5. All Process graphic displays with their attached tag names links and animations suppose to be tested during FAT and will not be done again except if default is discovered. 6. An operator interface (PC) shall be set up in the PIB building or MCB Control room, manned by a trained Technician, who shall monitor the systems response and mark up the check list as each input is tested. A representative of the vendor and one of SATORP could witness the tests. 7. Any problems relating to the systems shall be recorded in a punch list folder set up in the control room. Vendor representatives or Instrument Technicians shall resolve the problems, clear the item and sign off the punch list when the rectification work has been complete.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 146 of 244
8. The field teams shall note down any problems or deficiencies with the field instrumentation on a punch list and pass the punch list to the appropriate supervisor for resolution. The originator of the punch list shall off the items as they are completed. A Trouble shooting team could be foreseen is needed, but the deficiencies should be solved by the field instrumentation team as a first step. 9. All punch lists shall be prepared in accordance with SATORP Project Procedure. 10. Time saving could be realized if associated with loop checks, complex logics/controls are also scheduled: Functional checks for fire and gas systems, Functional checks for Emergency Shutdown System, Confirmation of alarms and trips set points and Burner Management System (BMS).
IV.4.1.3. Functional Test Sequence Functional tests of complex controls and/or logics should be commonly scheduled with loop check of basic functions allowing saving of time. Functional test results will be reported on "Functional test sheets" which are available for every type of basic function. IV.4.1.4. Commissioning Functional Test Sheet The following test sheets will be used for all the items according to the loop type: •
Analog Loop
•
Digital Loop
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 147 of 244
COMMISSIONING FUNCTIONAL TEST SHEET INSTRUMENT ANALOG LOOP P01
*J10065188* *J10065188* FJ01B - ANALOG LOOP
FORM :
BF : 011-F-0001 PID N° : SA-JER-DS011-TRJR-480002 TASK NUMBER : J10065188
TASK LOCATION :
ESTIMATED TIME (MH) :
EXPENDED TIME (MH) :
2
ONSHORE
Subsystem J0110101
PUNCH LIST ITEMS :
ASSOCIATED ITEMS 011-FC-0001, 011-FE-0001, 011-FT-0001
Associated datas Lo o p ta g :
T S D L R e v:
Associated tags
Yes No
NA
Comment
Unit Scale Square root extraction performed within the transmitter Square root extraction performed within the ICSS Value of the threshold 1 Value of the threshold 2 Value of the threshold 3 Value of the threshold 4 Line monitoring Associated ESD level tag
Note 1
Safety level tripped Associated outputs Comments
If necessary, additional sheet can be attached for comments No te 1 : When checking the trip condition, report this test on the Safety Logic Diagram by highlighting for instance the correspond input of the relevant safety level to avoid repeating this test twice No te 2 : This form might be amended as per the project ICSS or PLC Standard if necessary
Punch list ra ise d
YES
NO
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 148 of 244
COMMISSIONING FUNCTIONAL TEST SHEET INSTRUMENT DIGITAL LOOP P01
*J10065191* *J10065191* FJ01A - DIGITAL LOOP
FORM :
BF : 011-H-0600 PID N° : 02020-011-G-0001A-0036 TASK NUMBER : J10065191
TASK LOCATION :
ESTIMATED TIME (MH) :
EXPENDED TIME (MH) :
2
ONSHORE
Subsystem J0110101
PUNCH LIST ITEMS :
ASSOCIATED ITEMS 011-HS-0600-L
D a ta s
Loop tag:
TS LD-Rev:
W hen relevant loop type as per PID Symbol Instrument (e.g.Motor type M Associated tags
Yes No
NA
Comment
Normal state v ersus faulty process conditions
Equipment status
Priority selector for motors in duty /stand-by configuration Line monitoring input Line monitoring output Fail safe output Associated ESD level tag
Note 1
Safety level tripped Associated outputs Comments
If necessary, additional sheet can be attached for comments Note 1 : When checking the trip condition, report this test on the Safety Logic Diagram by highlighting for instance the correspond input of the relevant safety level to avoid repeating this test twice Note 2 : This form might be amended as per the project ICSS or PLC Standard if necessary
Punch list ra ise d
YES
NO
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 149 of 244
IV.4.2. Electrical Motor Run
The purpose of mechanical run is to check the mechanical performance such as differential absorbed current, vibration, noise, heat generation of equipment. Induction motors to be used as drivers for pumps, compressors, fans and blowers shall be mechanically run in. The mechanical run in will always comply with Vendor’s instructions and recommendation. The following motors shall be excluded from mechanical run in: 1. Motors for chemical injection pumps. 2. Motors for canned pumps. 3. Motors coupled with their service equipment. The running in of induction motors shall be carried out prior to coupling with their service equipment in order to check the motors for smooth operation, perform initial run in of moving parts and make adjustments, if required. All the technical data of the motor will be checked: a. Ambient Temperature. b. Bearing Temperature. c. Current. d. Voltage drop. e. Winding temperatures reading (if any). f.
Vibration analysis tests (If necessary).
When the bearing temperature rises and vibration measured after stabilization of continuous run-in is within the values specified in vendor’s instruction manual, mechanical run-in shall be deemed to be successfully completed.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 150 of 244
IV.4.2.1. Details for Implementation Remote Control Unit Test Tripping/closing contactors for induction motors shall be tested from the control station. Direction of Rotation Prior to the continuous run in, the direction of rotation of induction motors shall be checked. Continuous Run-in Induction motors to be used as drivers for pumps, compressors, fans and blowers, except motors excluded from mechanical run shall be continuously run in for: 1. Three hours for the low voltage induction motors under no load. 2. Four hours for the high voltage induction motors under no load. However, when these indexes are not stabilized within three hours (LV) or four hours (HV), run in period shall be extended until they are stabilized. IV.4.2.2. Commissioning Functional Test Sheet
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 151 of 244
COMMISSIONING FUNCTIONAL TEST SHEET ELECTRICAL LV MOTOR P01
*J10103201* *J10103201* FORM :
BF : 011-GM-0001-A
FP13 - LV MOTOR
CRUDE CHARGE PUMP MOTOR A PID N° : SA-JER-DS011-TRJR-480002 TASK NUMBER : J10103201
TASK LOCATION :
ESTIMATED TIME (MH) :
EXPENDED TIME (MH) :
5
ONSHORE
Subsystem J0110101
PUNCH LIST ITEMS :
DATA MANUFACTURER
RATING
kW SC/FLC
FRAME SIZE
VOLTAGE:
V TYPE OF PROTECTION
SERIAL NO.
CURRENT
A INSULATION CLASS:
DUTY
RPM
TEMP. RISE CLASS: RESULT
FUNCTION TEST REQUIREMENT
INITIALS
Check precommissioning activities have been carried out (refer to check list and test sheet). Check equipment for cleaness. Measure Insulation resistance value of motor windings and cables at 1000 V (Minimum value: 100 Mohm).
UVW - E =
Measure Insulation resistance value of motor anticondensation heater at 500 V. Minimum value 10 Mohm Energise motor anti-condensation heater and check related voltage & current at terminal box.
Mohm
Mohm
V
A
Energise control of motor starter and put starter in test position. Perform secondary injection test on protection relays and metering and record on attached sheet FTR-2. Check protection setting according relay protection study Carry out functional test of circuit breaker in local and remote configurations as indicated on attached sheet FTR-1 Test interface trips and signals (remote alarms & status) as indicated on attached Sheet FTR-5 Energise start and stop (impulse) motor uncoupled to check direction of rotation. If required, perform a 1 hour no load (uncoupled) test of the motor and record results in following table. Starting current
A
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 152 of 244
SAME TEST SHEETS WILL BE USED FOR THE FOLLOWING ITEMS:
SUBSYSTEM J0110101
J0110102
J0110103
J0110201
J0110202
J0110203
J0110204
J0110205
011-GM-0001A/B
011-AM-0006A/B
011-GM-0002A/B
011-GM-0042A/B
011-GM-0014A/B
011-AM-0004A/B
011-GM-0011A/B
011-GM-0009A/B
011-GM-0038A/B
011-GM-0024A/B
011-GM-0003A/B
011-KM-0002A/B/C
011-AM-0003A/B
011-GM-0013A/B
011-GM-0004A/B
011-KM-0003
ITEMS
011-GM-0039A/B 011-GM-0040A/B
SUBSYSTEM J0110206
J0110207
J0110208
J0110209
J0110302
J0110303
J0110304
011-GM-0012A/B
011-GM-0010A/B
011-GM-0008A/B
011-AM-0001A/B/C
011-GM-0018A/B
011-GM-0016A/B
011-AM-0005A/B/C
011-AM-0001D/E/F
011-GM-0017A/B
011-AM-0005D/E/F
011-AM-0001G/H/I
011-GM-0041A/B
011-AM-0005G/H
011-AM-0001J/K/L
011-GM-0015A/B
011-AM-0001M/N/O
011-GM-0020A/B
ITEMS 011-AM-0001P 011-AM-0002A/B/C 011-AM-0002D/E/F 011-GM-0005A/B 011-GM-0007A/B
SUBSYSTEM
ITEMS
J0110305
J0110306
J011SA00
J011UA11
J011UA12
J011UA13
J011UA14
011-GM-0029A/B
011-GM-0023A/B
011-GM-0025A
011-GM-0037A/B
011-GM-0030A/B
011-GM-0035A/B
011-GM-0032A/B
011-KM-0001
011-GM-0027A
011-KM-0005
011-GM-0031A/B
011-KM-0004A/B
SUBSYSTEM J011UL20
J011UL30
J011UM00
J011UW00
J011UZ00
011-GM-0028A/B
011-AM-0008
011-AM-0007A/B/C
011-GM-0006A/B
011-GM-0026A/B
011-AM-0007D/E/F
011-GM-0019A/B
ITEMS 011-GM-0021A/B 011-GM-0022A/B
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 153 of 244
IV.4.3. Tightness Test
This is normally the last stage before inerting and the introduction of hydrocarbon gases or liquids or chemicals and is a vital safety step in the start-up sequence. All equipment and pipe work shall have been tested during construction, but during the various stages described above many flanges, vents, drains, etc. will have been opened. The tightness test is a final system integrity check before introducing hazardous materials into the Plant. The leak test is to be carried out after final installation by air, nitrogen and the proper process. Insulation of flanges shall be done after the final pressure test of the section. Air or nitrogen is normally used at supply pressure, generally 4 -7 barg. As general rule tightness testing is to be executed according to P&ID diagram circuits marked up. The leak test pressure must not be higher than the design pressure of equipment or pipework. Note When the furnace and the reactors are heated up to a temperature of 450-550ºC all hot flanges must be hot bolted. The purging with inert gases which follows is to remove all air before the introduction of hydrocarbons or chemicals. The following procedure will be used to ensure that the unit is absolutely tight. When followed correctly, the chances that the equipment will have to be opened for leak repairs later will be minimised. The opening of the equipment after the introduction of hydrocarbons will cause delays because the equipment has to be isolated, drained, purged with nitrogen to remove the contents and then, after the repairs are carried out, re-inerted and tightness-tested. Detailed procedures for implementation of Tightness Tests shall be prepared based on this general procedure.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 154 of 244
When the planned commissioning tests are complete, the plant achieves Ready for Initial Start-Up (RFISU) status. The test shall be performed for all piping, vessel, process and utility equipment, and all their associated connections. For nitrogen, an air tightness test may be performed initially instead of a Service Test. Nitrogen will not be charged to the system until there is an operational requirement and a Company validation for it. The following items shall be excluded from the system undertaking the Test: •
Vent pipe.
•
Safety valve discharge pipes to atmosphere
•
Drain pipes to open basin.
•
Underground piping that has no flanges.
•
Flare stacks.
•
Heater casings.
•
Sprinklers.
•
Halon piping and deluge network downstream the control valves.
•
Atmospheric storage vessels.
Ancillaries of packages previously run at the Manufacturer’s. The system is pressurised with the test fluid to operational pressure and then checked for leaks at all the connections: •
Flanges/threads.
•
Screw connections.
•
Manholes.
•
Valves.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 155 of 244
Any leaks identified will be rectified and the system confirmed tight. The requirements for pre start-up leak tests and service test during initial start-up shall be as follows: •
For systems with maximum operating pressure greater than 6.894 MPa (1000 psi), a leak test with inert gas, followed by a service test, shall be conducted at the maximum operating pressure of the piping system.
•
For systems with maximum operating pressures less than 6894 MPa (1000 psi) a pre start-up leak test with inert gas shall be conducted at the available inert gas (not exceeding the maximum operating pressure) or pressure as recommended by the responsible of the Company, followed by a service test at normal operating pressure of the piping systems. When inert gas is not available, the service test will satisfy the pre start-up leak test requirements.
The pressure on the system will be brought up incrementally to the Maximum Normal Operating Pressure (If not defined 90% of the design pressure should be considered). It is however acceptable that the systems having a maximum operating pressure of less than 10 bars may be also tested at the instrument air pressure, even if the maximum pressure is not reached. Whenever the maximum operating pressure of the system is above the available air pressure, other means of pressurization are required to perform the leak test. Nitrogen shall be used as the leak testing means. The opportunity will be taken to re-use the nitrogen for the following nitrogen leak test, and to inert the leak tested system. Following a pressure test carried out with nitrogen at 20 bar, the oxygen content will be around 1%. Therefore the N2 high pressure leak test should normally be sufficient for inerting purposes.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 156 of 244
IV.4.3.1. Exceptions •
Pumps will be isolated and tested at their maximum suction pressure.
•
Centrifugal compressor will be isolated and tested at the compressor shutdown balance pressure.
•
Systems working under vacuum will be leak tested at 10% below the set point of the pressure safety valves.
IV.4.3.2. Quality Considerations and Acceptance Criteria Acceptance criteria for air and nitrogen test: The leak test will be considered successful if, at the test pressure, the fall in pressure is equal or less than 0.05 bar/hr. In the case of process gases with more than 100 ppm SH2, the accepted fall in pressure will be reduced to 0.03 b/hr. In the case of systems operating under vacuum, the test criteria will be a pressure increase equal or less than 0.02 b/hr. Principle of Fluid to be Used The principle is to test a system by using an inert fluid close as far as possible of the characteristic of the target fluid. Non- Hydrocarbons System All non Hydrocarbon system shall be tested with the target fluid, as follow: •
Water shall be used for Fire water, water services.
•
Air shall be used for air services.
•
Nitrogen shall be used for nitrogen services
•
Etc…
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 157 of 244
Hydrocarbon System For the system processing hydrocarbon or chemical, principle shall be defined as follow: •
Oil system at low pressure (#150 series), assumed as single phase oil to be tested with water.
•
Chemical product system, particularly those one blanketed by gas or nitrogen to be tested with nitrogen.
•
Sweet gas system ( Fuel gas, gas treatment), propane , single phase oil from #300 series and multi-phase oil to be tested with nitrogen.
IV.4.4. Drying of Piping And Equipment
In general, drying will be applied to the following installations: •
Refractory of furnaces.
•
Pipes or equipment where normal operating fluid is air or gases, once they have been water hydraulic tested and/or chemical cleaned and/or water flushed.
•
Pipes or equipment where normal operating fluid is a chemical product which is incompatible with water: o Hydrocarbon pipes and equipment o Lube oil systems
Drying can be distinguished into two different categories: •
Simple drying: until water free.
•
Critical drying: To a specific dew point.
In order to carry out an effective drying of the system lines shall be split into smaller sections and dried one by one. Especial attention shall be paid to process systems:
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 158 of 244
•
For instrument air system, instrument department shall purge the impulse lines of instruments as they are commissioned.
•
Confirm the suitability of hoses and the portable equipment to be used.
•
Piping and equipment subsystems will be depressurized / pressurized and/or air swept with instrument air or dry air from temporary compressor as per a timing sequence and circuit wise in order to remove moisture.
•
The vented gases will be tested for dew point. The detailed Precommissioning procedure will provide instructions and guidelines as required.
Conduct drying in accordance with system / subsystem detailed procedures. During drying, periodically check the sample points for dryness. On completion of the drying, the system shall be left with a small flow / purge until needed. Then, before further start up activities, samples shall be taken to confirm that the dew point of the air has not increased. Proceed to further dry-out if dew point has increased. Isolate the dried system by closing isolation valve or by putting blinds to avoid the invasion of moisture into the system. If the system requires inerting then as soon as possible after drying pressurize the system to 0.2-0.3 barg with nitrogen and hold. IV.4.4.1. Refractory Dry-out Refractory dry-out must be carried out carefully following the manufacturer’s dry-out curve precisely taking also into consideration the following notes. The purpose of the dry-out is to remove water in 2 phases: 1. Free water, which might by laying on the surface of the refractory, laying between the casing of the furnace and refractory, laying in cracks or between bricks.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 159 of 244
2. Water of crystallization, water crystals is formed during the mixing, application and initial drying of the castable refractory. These crystals must be slowly vaporized during the second phase of the dry-out. During the dry-out period, water that has accumulated in the refractory must be vaporized slowly. This is to prevent the water boiling violently and spalling the castable lining and/or lifting up of the furnace floor. lf the furnace is idle during cold/freezing periods it is important that space heaters are installed or lighting a few burners to prevent water laying in the refractory from freezing. Water freezing will cause refractory damage. lf water enters the furnace after the initial dry-out has been completed the dry-out must be repeated. During the dry-out period of the furnace the nitrogen circulating stream also dries out the process gas boiler. Regular checks of the furnace casing and process gas boiler shell are necessary. Hot spots on the casing of the furnace or process gas boiler can occur if free water is boiling too quickly between the refractory and casing/shell. In this case an additional holding period must take place until the hot area temperatures have reduced indicating that the water has been removed. When lighting the burners during the dry-out phase maximum combustion air flow rate must be utilized. This is to help the removal of water vapours and good heat distribution through the furnace during low temperatures. The burner lighting sequence must be used until required temperature is reached. During this phase, alight burners must be rotated. This is to ensure that the heat distribution will be uniform and to check the operation of the burners and that the muffle block is checked. When the burners are lit do not put them on radiant, but maintain a sort yellow flame by slowly closing in the burner air register. Maintain the lowest possible fuel gas pressure to the burners this is to ensure that the maximum number of burners is lit and for good heat distribution. The bridge wall temperature thermocouple is the only temperature variable to be used for the dry out curve.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 160 of 244
IV.4.4.2. Dry-out Procedure 1. Fill the boiler steam generation system with water (and chemicals if the boil out is to be carried out at the same time) to 60%. 2. Establish nitrogen circulation flow through the catalyst tubes. Around 60-70 Nm3/h per catalyst tube. 3. Prepare for burner lighting as per Reformer vendor burner management system (BMS) and following section. 4. Ignite burners, utilizing the burner lighting sequence to maintain the dry out schedule. 5. Increase the bridge wall temperature according to manufacturer instructions, as example: a. Increase the bridge wall temperature at 15°C per hour to 120°C hold for 24 hours. b. Increase the bridge wall temperature at 15°C per hour from 120°C to 150°C hold for 24 hours. c. Increase the bridge wall temperature at 15°C per hour from 150°C to 300°C hold for 24 hours. d. Increase the bridge wall temperature at 15°C hour from 300°C to 550°C hold for 24 hours. When the dry-out of the furnace and process gas boiler has been completed the reformer can be shutdown for inspection of the furnace, process gas boiler and steam drum. Reduce the bridge wall temperature at a maximum rate of 25°C per hour. When the bridge wall temperature indication is reading less than 3 mm. Check for voids in the refractory. 2. Check the tube sheet for damage to the ferrules. 3. Ensure the tubes are clean by blowing through with air.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 163 of 244
4. Check the by-pass valve, ensure it is functioning correctly. 5. When all the inspections are complete and repairs, if any carried out. Close all the manways and heave the process under N2 pressure after purging out the O2
IV.4.5. Purging with nitrogen
It is assumed that all pre-start operations including drying and catalyst loadings have been completed together with the mechanical check of the unit. It is also assumed that all lines have been tested and washed. Purging operations have to be done with nitrogen introduced by means of temporary connections. The best procedure for purging involves repeated pressurisation of the system with nitrogen, followed by blow through and depressurisation down to atmospheric pressure. This procedure is repeated until the oxygen content in the equipment and lines is reduced to less than 0.1% by vol. Drager tube or portable oxygen analyzer can measure the oxygen content. Once purging operation has started, it would be better to continue uninterrupted, until the oxygen content has been reduced to the desired level. The quantity of nitrogen required for purging can be established by estimating the volume of the section to be purged and this can be done with the help of the P&ID diagrams which are also used to programme and control the operation. It is recommended to subdivide the plant into various systems in order to optimise the nitrogen consumption. After having defined which system is to be purged first, the same nitrogen can be used in successive systems provided the conditions allow it to do so. In this manner the overall consumption of nitrogen can be reduced. This procedure can only be done for the first start-up, when the plant is devoid of hydrocarbons or after a major plant shutdown. The pre-commissioning team just prior to start-up, taking into account the above mentioned points, will perform a detailed programme of purging operation. Follow the intermediate procedure CDU/VDU Preparation for Start-Up (011-IP-0001), Attachment 32
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 164 of 244
IV.4.6. Operational Tests
Once all basic functions of a subsystem have been functionally tested, the subsystem will be subject, wherever applicable, to an operational test. This operational test consists of bringing the subsystem equipment into operation under conditions as close as possible to normal, during a significant period, not only to live test the automated devices, controls, normal and shutdown sequences, but also to reveal possible mechanical or electrical faults (water tightness, vibrations, overheating, overloading, etc.), which may occur during prolonged normal use. The purpose of the operational tests is therefore to prove that the main equipment is mechanically sound, and that each subsystem, as a whole, is ready for normal operation. The operational tests are the key commissioning activity: the establishment of relevant Procedures, the tests preparation and their execution, the engineering of temporary facilities wherever required to allow operational testing, the organization and the supply of all required means, are part of the commissioning scope of work. As a general rule, will be subject to an operational test: •
All subsystems including major mechanical equipment. Typical examples: o Fire water pumps. o Air and process compressors. o Power generators.
•
A number of subsystems which, although they do not include major rotating equipment, perform a vital function of the plant. Typical examples: o ESD/F&G. o Hydraulics.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 165 of 244
o Deluges.
IV.4.6.1. Pumps and Driver Run-in The running-in of the process pumps can be performed by water during the washing of the unit. Before the equipment is ever started it should be checked as follows: •
Review carefully the manufactures operating instruction.
•
Verify that the pump and driver are properly aligned.
•
Check that all cooling water piping to pumps is correctly installed.
•
Check gland or seal oil piping. When a pump is furnished with mechanicals seals, verify that all components of the flushing system such as strainers, separators, restriction orifices and coolers have been correctly installed and are clean.
•
Verify that bearings shafts are clean and properly lubricated. All bearings should be flushed clean and the correct lubricant in the proper quantity must be provided. Record type of lubricants used and date of lubrication.
•
Install temporary strainers at the suction of each pumps.
•
Rotate pump and driver by hand, checking that they turn freely.
•
Check that run-in water supply and delivery circuits are lined up.
•
Open suction valves fully, venting air from piping and pump completely, filling with liquid.
•
Put pressure gauges in service.
•
Ensure that electrical power is available from switchgear to starter of electric motor drivers. For steam turbine drivers, the turbine is warmed by slowly opening exhaust valve. Back in steam while draining water from casing.
•
Exhaust valve is always fully opened before starting. Where exhaust system is under vacuum, as must be warmed by gradually introducing driving steam, after opening exhaust valve. In vacuum exhaust system, sealing steam must be
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 166 of 244
admitted to turbine shaft labyrinths to avoid loss of vacuum and to prevent air from entering system. •
Crack open discharge valve of centrifugal pump and fully open discharge valve of positive displacement pump before starting.
•
Start pump and bring up speed immediately, observing discharge pressure.
•
Partially open discharge valve to give a flow adequate for testing the pump, avoiding motor overload.
•
In event of unusual noise, vibration, overheating or other abnormal condition, shut down immediately. Correct cause before resuming operation.
•
Check shaft sealing. Mechanical seals should show no leakage. Conventionally packed stuffing boxes must always be allowed to leak slightly to provide some lubrication and prevent overheating. Stuffing box nuts are generally only finger tight. A mechanical seal may show leakage on start-up. After pump has been started and stopped a few times, leakage should stop. If seal leakage persists, action must be taken to correct problem.
•
If pump is to be tested with a liquid with higher than design specific gravity, take special care to avoid motor overload. Discharge valve must be throttled and the motor amp. Loading checked. Avoid restricting discharge to the extent that it will cause internal recirculation and excess heat generation.
•
The discharge valve of an operating positive displacement pump, (rotating or reciprocating), should never be closed as casing can be overpressurised.
IV.4.6.2. Compressor and Motor Run-in In principle, vendor gives the operation and start-up instructions for compressors and pumps and the instructions given below are only intended as a general rule and should never supersede the VENDOR procedure. Intermediate procedures have been written for the compressors of the unit, based on the Vendor procedure and the CDU/VDU Process licensor: Compressor 011-K-0001 Shutdown/Degassing/Gassing/Start‐Up (011-IP-0010)
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 167 of 244
Before start-up, the engineer in charge should be familiar with the vendor instructions and follow the vendor instructions all through the start-up. The compressor may have been idle for some time. A check should therefore be made to see if the compressor has been run in. The mechanical supervisor normally does this. If the machine has been run in, the auxiliary lube oil pump should be started once a day. If the loading valves have been removed or pipe work disconnected, the open ends must be covered to prevent entry of foreign material or water into the compressor. Initial check After completing the compressor check list and a function test of all alarms and trips are fully operational, all necessary personnel must be informed about the intention to start. The auxiliary lube oil pump should be started about 20 minutes prior to the compressor start, to check its operation and to warm up the bearings. If the compressor lube oil pump is of the manual type, the oil pressure should be brought up to operating pressure several times to be sure that all lubrication points have been provided with oil, prior to the start-up. During this time, check the operation of the loaders and ensure that there is no liquid in the suction, interstage and discharge knock-out drum or pipe work. Also ensure that the compressor is free moving by rotating the shaft 450°. Purge the compressor with nitrogen if there is a possibility of presence of oxygen. Start-up Pressurize the compressor by opening of the suction block valve. When the machine is up to pressure, closes it again and checks for leaks. Check that the electric motor is in the “on” position. Start the cylinder lubrication. If these cylinders are not of the shaft-driven type, check their operation. The cylinders are normally set at maximum during running in and initial operation, then reduced to optimum when the pistons have been worn in. Open all discharge block valves.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 168 of 244
The main motor can then be started. Leave for a moment to allow it to run up to speed. When the motor is up to speed, put the auxiliary lube oil pump into the automatic start position and allow the main lube oil to take over. The suction block valve can then be opened. This must be done slowly to avoid overloading the machine by a sudden surge of gas. Allow it to run for a minute unloaded and check the operation of the cylinder lubricators (that is if they are driven from the main shaft). Also, note the Amps. Loading In principle the compressor should not be running unloaded for a longer period, and should be loaded as soon as possible to avoid over-heating. With the motor running correctly and all suction and discharge valves open, the compressor may then be loaded. The compressor must always be loaded from the driver end to outboard end (unloading is the reverse of this). Always check the manufacturer’s starting/operating instructions. Running check list Most of the time there is a vendor recommended checklist. If this checklist is not available, the following general rules can be followed. When the machine is fully loaded, or partially, if designed that way, the following items should be checked regularly: •
Suction and discharge temperatures
•
Jacket temperatures (where applicable)
•
Interstage temperatures (where applicable)
•
Lube oil temperatures
•
Suction, interstage and discharge pressures
•
Lube oil pressures
•
Motor Amps
•
Pressure drop over lube oil filters
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 169 of 244
•
Use of utilities like nitrogen, steam, cooling water, etc.
At normal operation, these shall be checked minimally 2 times each shift. During initial operation these should be checked more regularly and at each load change.
IV.4.7. Inter-Departmental Coordination
Notification should be given to the other departments of the refinery which will concerned with the upcoming start-up; off-sites/storage, other process units integrated with the unit, utilities, maintenance and instrument departments and the laboratory. During the start-up phase, additional manpower should be made available from the operating, maintenance, and instrument departments, in order to assist in unit labour coverage. In addition, the final laboratory schedule should be posted and the laboratory alerted, so that the required quality control tests can be carried out as and when required.
IV.4.8. Utility headers Commissioning
These headers may have been temporarily commissioned during the precommissioning phase. For ease of upstream operation, the utility system should be put into service as soon as possible. The various lines must be tested for leakage and washed free of debris and construction trash. Air headers must be checked for water, and gas headers for water and condensates. Here is a non restrictive list of these systems and the status under which they are expected to be. Some of the systems may not be applicable, depending on the unit: In service means the system is operational: main header and user’s feeder lined up. Each individual user only is isolated either by block valves, if available, or blinds. Ready to use means the system (main header, individual user feeders) has been flushed / cleaned, dried if required, leak and pressure tested and left under the
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 170 of 244
appropriate atmosphere. The main header has been subsequently shut-off with block valves and blinds. •
Instrument air: In service.
•
Plant air: In service.
•
Cooling water system: In service, individual users isolated, drain open.
•
Nitrogen system: In service and checked for proper oxygen content.
•
Steam: In service, drains and traps have been checked. Steam lines should be warmed-up slowly to prevent damage by water hammer. All steam traps and control valves in the system are to be placed in service for purpose of testing. High pressure to low pressure steam letdown systems must be operational.
•
Fire water: In service.
•
Flare system: Ready to use. (The unit flare main header of the unit is kept open to atmosphere and isolated with blinds from the Refinery flare collector at the battery limit - depending on site circumstances).
•
Electrical equipment: Ready to use. Electric motors have been run in for 4 hours (disconnected from the driven machine).
All wiring, junction boxes, breakers, switches grounding and so on have been checked for correctness and compliance with specifications. The different electricity network will be checked and the different automatic switches in the power supply tested: •
Electrical power to instruments by the auxiliary / UPS power system.
•
Automatic transfer from the regular transformer to the stand-by.
For the utilities of the unit, follow the intermediate procedure: •
011-IP-0014, Utilities Start-Up/Shutdown.
•
011-IP-0015, Combustible Fuel Gas Gassing/Start-up/Shutdown/Degassing.
•
011-IP-0016, Flare System Gassing/Start-up/Shutdown/Degassing.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 171 of 244
IV.4.9. Unit Gas In
Follow the intermediate procedures CDU/VDU Preparation for Start-Up (011-IP-0001), Attachment 32 and CDU/VDU Start-Up (011-IP-0002), Attachment 33
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 172 of 244
V. START-UP PROCEDURES For start-up procedures refer to the following Intermediate Procedures: •
CDU/VDU Start Up, Attachment 33
•
Amine Section Gassing/ Start-Up/ Shutdown/ Degassing, Attachment 36
•
Steam Generation Start-Up/ Shutdown, Attachment 37
•
Tempered Water System Gassing/ Start-Up/ Shutdown/ Degassing, Attachment 38
•
Close Drain Gassing/ Start-Up/ Shutdown/ Degassing, Attachment 39
•
E-0016/17/18 Gassing/ Start-Up/ Shutdown/ Degassing, Attachment 40
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 173 of 244
VI. NORMAL OPERATION
VI.1. Operation of CDU/VDU As long as process conditions are within acceptable limits according to the process design data, the Crude distillation Unit shall be kept at the operating conditions as per PFDs and Heat and Material Balance (see Attachment 2 and Attachment 5). The CDU/VDU can be working in several operating modes: •
Base Case: Naphtha/Kero TBP Cut Point 145 ºC
•
Maxi Kero: Naphtha/Kero TBP Cut Point 140 ºC
•
Maxi Naphtha: Naphtha/Kero TBP Cut Point 160 ºC
•
Kero in Diesel Pool: LVGO/MVGO Cut Point maximized
•
Naphtha splitter Reboiler Duty = 15 GCal/h Case
Some operating conditions shall be adjusted from one case to the other as per the set points given in the chapter “III.2 Description of Flow” and also shown in the PFDs and in the Heat and Material Balances of the unit for each operating case. As explained in chapter “III.3 Process Variables”, several parameters can be adjusted to adapt the unit in order to obtain the products yields and the adequate quality.
VI.1.1. Operating Flexibility
The CDU/VDU has been designed for normal operation between 60% and design capacity.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 174 of 244
VI.2. Alternative Operating Modes Additionally the following cases have also been taken in consideration in the design of the unit:
VI.2.1. VDU Bypass
When the Vacuum Distillation Section requires being down for decoking, this can be bypassed and the Atmospheric Residue feeds directly to the DCU (Delayed Coker Unit). During the by-pass of the VDU section, the Atmospheric Residue will be pumped and cooled down in the heat exchangers that are normally operating with Vacuum Residue before being sent to the DCU. This operation shall also have the possibility to either maximize the flow to the DCU or to send the entire Atmospheric Residue to storage what requires extra cooling. The unit under VDU by-passing will operate at turndown condition, i.e. 60% of the design capacity (i.e. 120000 BPSD). The cut point and specifications for all the atmospheric distillation products are the as defined for the Base Case. For further details of VDU Bypass procedure, refer to Attachment 41.
VI.2.2. Light Arabian Crude Case
In case of long term shutdown of DCU it is necessary to switch over from Heavy Arabian crude to Arabian Light Crude feed to CDU/VDU, in order to limit the amount of fuel oil export and go on with refinery operations. To avoid thermal and hydraulics bottlenecks in the unit, the following changes to the operating conditions shall be implemented: •
Reduce the crude feed to CDU/VDU to 90% of normal capacity for the Heavy Arabian Case. i.e. 1061.3 t/h per train (185000 BSPD)
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 175 of 244
•
Adjust Naphtha/Kerosene Cut Point at 150ºC to increase naphtha recovering and reduce kerosene recovering, in order to balance underdesign on each product and maximize Light Arabian crude capacity.
•
Modify the LVGO Cut Point to maximize the specification on ASTM D86 95% vol of the total cut LAGO+HAGO+LVGO < 360°C
•
Increase Preflash inlet temperature to 206ºC.
•
Increase the striping steam of Preflash Column to 6t/h to compensate intermediate preheat train lower performance.
•
Open partially the manual by-pass of E-0005 crude side and HV-0001 on E0003 by-pass for better adjustment of the temperature at Desalter inlet.
Some flow rates and temperatures shall be adjusted for this case as given in the in the PFDs and in the Heat and Material Balances, Attachment 6.
VI.3. Special Checks
VI.3.1. Desalter Interface Level
It is very that the crude/water interface level in the desalters be checked regularly. For this purpose, trycock valves spaced at intervals with internal extensions are provided in each vessel. It is recommended that the interface level be verified at least once per shift by opening each valve and observing the flow from the various levels. High interface level will usually increase electric load, while low level may allow oil to be discharge with the effluent water. Interface should be at the middle trycock approximately.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 176 of 244
VI.3.2. Chemical Injection Systems
VI.3.2.1. Demulsifier The Demulsifier is delivered by supplier in proprietary drums. First, it has to be transferred to the drum D-0031 of Injection Package X-0003, using the dedicated connection and an external portable pump. Then, the Demulsifier is injected into the Crude feed and desalter inlet lines by means of the pumps, G-0030A/B and G-0031A/B, respectively. The drum is sized to give a hold-up time of 5 days at maximum chemical consumption. So, the system shall be refilled at least once per week. At normal dosing flow rates, the hold-up time is about 15 days. Once per day the operator shall verify at field that the system is working properly: •
One pump per injection point is in operation.
•
The drum liquid level is above minimum level.
•
The system is injecting enough quantity according to the plant capacity. Approximately the variation of level is around 15 cm per day with the pumps working at normal capacity (14 l/h per pump).
VI.3.2.2. Neutralizing Agent The Neutralizing Agent is delivered by supplier in proprietary drums. First, it has to be transferred to the drum D-0032 of Injection Package X-0004, using the dedicated connection and an external portable pump. Then, the Neutralizing Agent is injected into the preflash, atmospheric and vacuum overhead lines by means of the pumps, G0032A/B, G-0033A/B and G-0034A/B, respectively. The drum is sized to give a hold-up time of 5 days at maximum chemical consumption. So, the system shall be refilled at least once per week. At normal dosing flow rates, the hold-up time is above 10 days.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 177 of 244
Once per day the operator shall verify at field that the system is working properly: •
One pump per injection point is in operation.
•
The drum liquid level is above minimum level.
•
The system is injecting enough quantity according to the plant capacity. Approximately the variation of level is around 9 cm per day with the pumps working at normal capacity (0.9 l/h per pump).
VI.3.2.3. Corrosion Inhibitor The Corrosion Inhibitor is delivered by supplier in proprietary drums. First, it has to be transferred to the drum D-0033 of Injection Package X-0005, using the dedicated connection and an external portable pump. Then, the Corrosion Inhibitor is injected into the preflash and atmospheric overhead lines by means of the pumps, G-0035A/B and G-0036A/B, respectively. The drum is sized to give a hold-up time of 7 days at maximum chemical consumption. So, the system shall be refilled at least once per week. At normal dosing flow rates, the hold-up time is above 19 days. Once per day the operator shall verify at field that the system is working properly: •
One pump per injection point is in operation.
•
The drum liquid level is above minimum level.
•
The system is injecting enough quantity according to the plant capacity. Approximately the variation of level is around 5 cm per day with the pumps working at normal capacity (G-0035A/B: 0.6 l/h and G-0036A/B: 0.9 l/h).
VI.3.2.4. Phosphate The Phosphate could be liquid or powder form. It is delivered by supplier in proprietary drums. First, it has to be transferred to the drum D-0034 of Injection Package X-0006, using the dedicated connection and an external portable pump. If phosphate is available in powder form, it has to be added through the opening on the top.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 178 of 244
In the drum, the phosphate shall be diluted until 2%wt with demineralized water. The water is added by opening the manual globe valve in the DWA supply line. A turbine type mixer (K-0005) is provided to blend the solution. Then, the Phosphate is injected into the steam generator by means of the pumps, G-0037A/B. The drum is sized to give a hold-up time above 21 days at maximum chemical consumption. So, the system shall be refilled at least once per month. At normal dosing flow rates, the hold-up time is above 35 days. Once per day the operator shall verify at field that the system is working properly: •
One pump per injection point is in operation.
•
The drum liquid level is above minimum level.
•
The system is injecting enough quantity according to the plant capacity. Approximately the variation of level is around 3 cm per day with the pumps working at normal capacity (0.8 l/h).
VI.3.3. PZV Mechanical Interlocks The description of the PZV mechanical interlocks is included in attachment 88. In this document is also included the list of PZV and the corresponding mechanical interlock
VI.4. Problem during Normal Operation
VI.4.1. Off-Spec VGO
In case the VGO (MVGO+HVGO) is off-spec, it could be sent to Slop Oil tank in Unit 681. However, the VGO stream shall be cooled down by means of Slop Cooler E-0037 Before alignment of VGO to the slop system, the operator shall ensure that all manual block valves of the process and cooling water side of the E-0037 are completely open, to prevent that hot liquid could be sent to offsite tank. The control valve HV-0018 in CW side shall be 50% open by means of HC-0018. After flow of off-spec VGO through the E-0037 begins, the CW flow rate must be adjusted by slowly closing the HV-0018 until get the desire temperature at process outlet side (TT-
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 179 of 244
0050). To avoid no flow condition in the cooling water side by failure of HC-0018 or operator error, a mechanical stop in HV-0018 is provided at 43% of normal flow rate. Additionally, there is the option of add flushing oil to help cooling down the hot off-spec products to slop & CDU/VDU long recirculation, through injection line 6”-FLO011099305. Whenever use flushing oil to cooling down these streams is required, other prevention measures and safeguards are needed to protect the FLO system from possible overpressure of process circuit. With this purpose, a double check valve in line 6”-FLO011099305 and relief valve (PZV-0093) in FLO header have been provided.
VI.4.2. Tempered Water
In case of failure of the Tempered Water system, VGO at high temperature could be sent to storage. This event is detected by TAH-0202 at the process side outlet of E0030A/B. The operator shall notify immediately the offsite unit and try to route all VGO product to DHC/MHC, in order to ensure that hot liquid to storage goes only for short term. Refer to Attachment 50 for further details of the procedure in case of Loss of Tempered Water.
VI.4.3. Failure of Boiler Feed Water Valves Associated to Desuperheaters
In case of low temperature detected in MPS to C-0001/ X-0001 (TAL-0194/ TAL-0155), LPS to C-0002 (TAL-0359) or LPS to C-0003 (TAL-0180), verify status of TV-0233, TV0043 and TV-0049 respectively in order to verify if valve is failing open. In that case, isolate the control valve and feed boiler feed water to the corresponding desuperheater through the bypass of the control valve.
VI.4.4. Heat Exchanger Leakage Control
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 180 of 244
To detect any leakage in the heat exchangers refrigerated with soft or auxiliary cooling water leading to contamination of this system, the following actions shall be developed: •
If the hydrocarbon which is leaking to the system is in liquid phase, take a sample once per two weeks in the battery limit supply and return drains and analyze oil content. If there is significant difference of content between the return and the supply, similar approach shall be developed at the inlet and at the outlet of the individual heat exchanger in order to detect which one is leaking.
•
If the hydrocarbon which is leaking to the system is in gas phase, open a little bit the vent at the highest point of the system once per two weeks. While doing it, bring an explosivity meter next to the vent and if explosivity is detected then there is possibility of leakage. If this is the case, the same approach shall be developed at the high point just at the outlet of the heat exchanger (i.e. vent at the suction of the PZV installed at the cooling water outlet line).
Similar procedure shall be followed for heat exchangers and reboilers heated up with MP or LP steam where process side pressure is higher than steam side.
VI.4.5. Hydrocarbon in Sour Water Recovery Drum
The sour water separated in all the overhead drums, i.e. D-0003, D-0004, D-0005 and D-0008, is collected in the Sour Water Recovery Drum D-0006. In an upset condition, the water could carry over hydrocarbon (naphtha) drops into the D-0006. For detection of buildup of hydrocarbons in the D-0006, a radar type level transmitter (LT-0100) has been provided. Whenever high hydrocarbon level was detected in the drum, the operator shall remove the water/hydrocarbon interface by opening the block valve of the drum lateral drain (D2).
VI.5. Maintenance During maintenance the following verifications/operations shall be carried out:
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 181 of 244
VI.5.1. Thermal Relief Valves
In case the thermal relief valve TZV-0013 (E-0009A/B tube side outlet) or the TZV-0015 (E-0014A-F tube side outlet) has to be removed for maintenance, this must be replaced immediately with the spare relief valve stored in the warehouse. The system should never leave without protection for thermal expansion.
VI.5.2. Control Valves
When maintenance of a FO valve with only one drain is to be done, operator shall be sure that the control valve is really opened when draining and degassing. The system shall be effectively depressurized before removing any element of the system. For the HVGO and Vacuum Residue, all the control valve are provided with two drains, independent of the fail position, due to the high pour point and viscosity of the fluids.
VI.5.3. Cooling Water System
As per surge analysis for auxiliary cooling water lines for Jubail Export Refinery, when it is required to close the battery limit valves in this system, operator shall ensure that the closing time is 1 inch/second or slower.
VI.5.4. Steam-out
Equipment designed for half vacuum shall not be steamed out if the equipment is isolated. Vent connection to flare or atmosphere shall be opened before starting the steam out and once finished the steam-out operation, the vent valve shall be only closed when ambient temperature is reached.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 182 of 244
VI.5.5. Blind Position
Whenever an equipment is put out of service for maintenance purposes, blind around the equipment shall be changed to closed position. Operator shall verify the correct location of blind before any operation is done.
VI.5.6. Drainage of Residue to Closed Drain
For draining of equipment or lines into the closed drain system (CLD), containing HVGO, Atmospheric or Vacuum Residue, is required to thoroughly flush with flushing oil, in order to empty them of high pour point products that can plug the system. The next general steps shall be followed: •
Swing isolation blind of flushing oil and close drain connections to open position.
•
Close inlet block valve and leave the fluid temperature to cool down partially.
•
Close outlet block valve to isolate the equipment or line completely.
•
Open low point drains to CLD to empty the line or equipment while monitoring temperature in drum D-0014 by TI-0262.
•
Open the valve of flushing oil and monitor pressure in the system and level in drum D-0014.
•
Close the valve of flushing oil and swing isolation blind to closed position.
After flushing, the line or equipment should be degassed with steam through UC connection. The close drain drum D-0014 is provided with a steam coil to avoid plugging of high pour points or viscosity fluids.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 183 of 244
VI.6. Corrosion
VI.6.1. Corrosion Mechanism
The more relevant degradation mechanisms for the equipments and lines of the Crude Distillation Unit are indicated in the Attachment 1 of document: Corrosion Control Plan (SA-JER-DS011-TRJR-677302). This attachment also includes the minimum design implications applicable for each one. In addition, the equipment and lines can be affected by general degradation mechanisms. The Atmospheric Corrosion is an electrochemical process that requires the presence of an electrolyte and it could occur in any equipment of piping not externally protected. Corrosion under Insulation, that is the corrosion of piping and vessels that occur beneath insulation as a result of water penetration and it could occur at operating below 120ºC.
VI.6.2. Inspection
The requirements of inspection for corrosion monitoring are indicated in the Corrosion Control Plan (SA-JER-DS011-TRJR-677302). The corrosion detection and monitoring techniques employed for assessment of corrosion damage identified for CDU/VDU are: On Stream Inspection, Turnaround Inspection, Corrosion Probes and Sample Points.
VI.6.3. Corrosion Probes and Injection Points
For Crude Distillation Unit, corrosion probes were installed where corrosion rate data can be plotted in real time in: •
The Preflash Naphtha Reflux. In the pipeline from the Preflash Reflux Drum 011D-0003 to the Preflash Column 011-C-0001. Tag. 011-AT-0032.
•
CDU Overhead. In the pipeline from the top of the Atmospheric Column 011-C0002. Tag. 011-AT-0033.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 184 of 244
•
CDU Naphtha Reflux. In the pipeline from the CDU Reflux Drum 011-D-0004 to the Atmospheric Column 011-C-0002. Tag. 011-AT-0034.
•
VDU Overhead. In the pipeline from the top of the Vacuum Column 011-C-0003 to the Precondenser Exchangers 011-E-0025. Tag. 011-AT-0035.
•
Preflash Column Overhead. In the pipeline from the top of the Preflash Column 011-C-0001 (line 24”-NPH-011011001-101CH2S-P). Tag. 011-AT-0036.
Moreover, complimentary other corrosion probes were installed, but in this case after a period of service the coupons shall be removed, reweighed and measured and the corrosion rate calculated. Visual inspection of the coupons will provide information on the type of corrosion occurring and any corrosion deposits that form on the coupons could be analyzed. •
Line of exit (tube side) of 011-E-0003`s. Installed 5 Local mounted device probes of the type Retractable System Coupon Holders and Coupons.
•
Line of exit (shell side) of 011-E-0004`s. Installed 3 Local mounted device probes of the type Retractable System Coupon Holders and Coupons.
•
Line of exit (shell side) of 011-E-0025 A. Installed 1 Local mounted device probe of the type Retractable System Coupon Holders and Coupons.
The required injection points of CDU/VDU are indicated in the Corrosion Control Plan. All detailed information relative to them is explained throughout the document. For this Unit, injection points are: Neutralization to form a water-soluble salt less corrosive for the components made of carbon steel such as the overhead systems of the pre-flash and CDU/VDU columns, Filmic Amines used as corrosion inhibitor that adhere to the internal surface of pipes, and Phosphate Injection to prevent the formation of deposits in the surfaces of the steam generator tubes and caustic corrosion attack. The routine chemical analyses of the water provide information to verify the efficiency of the applied anticorrosive systems.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 185 of 244
VII.
NORMAL SHUTDOWN PROCEDURE
For shutdown procedure refer to the following Intermediate Procedures: •
CDU/VDU Shut Down, Attachment 34
•
CDU/VDU Gas Out, Attachment 35
•
Amine Section Gassing/ Start-Up/ Shutdown/ Degassing, Attachment 36
•
Steam Generation Start-Up/ Shutdown, Attachment 37
•
Tempered Water System Gassing/ Start-Up/ Shutdown/ Degassing, Attachment 38
•
Close Drain Gassing/ Start-Up/ Shutdown/ Degassing, Attachment 39
•
E-0016/17/18 Gassing/ Start-Up/ Shutdown/ Degassing, Attachment 40
•
VDU Bypass, Attachment 41
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 186 of 244
VIII. EMERGENCY SHUTDOWN PROCEDURES For emergency shutdown procedures refer to the Intermediate Procedures: •
General Emergency Shutdown, Attachment 42.
•
Loss of Instrument Air, Attachment 43
•
Loss of Power Electric System, Attachment 45
•
Loss of Cooling Water, Attachment 46
•
External Fire, Attachment 54
•
Loss of Pilot Gas, Attachment 44
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 187 of 244
IX. UPSETS SCENARIOS For information about the procedures during upset scenarios refer to the following Intermediate Procedures: •
VDU Bypass, Attachment 41
•
Shutdown with Large Recirculation, Attachment 47
•
Loss of LAGO PA, Attachment 48
•
Loss of HAGO PA, Attachment 49
•
Loss of Tempered Water, Attachment 50
•
Loss of BFW, Attachment 51
•
Loss of HVGO, Attachment 52
•
Loss of Desalter Water, Attachment 53
•
Loss of Flow Wash Oil Bed 1, Attachment 55
•
Loss of LVGO PA, Attachment 56
•
Loss of MVGO/HVGO PA, Attachment 57
•
Loss of Quench Bottom of C-0003, Attachment 58
•
Loss of Pump G-0018 Vacuum Residue, Attachment 59
•
Loss of K-0001 Compressor Off-Gas, Attachment 60
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 188 of 244
X. ANALYTICAL REQUIREMENTS
X.1. Sample Schedule CRUDE FEED FROM STORAGE Stream
CRD-001005
Service Description
CRUDE
Sample point
SC-0001
PID N°
480002
Analysis Performed
Frequency
Value
Test Method
Specific Gravity (15ºC)
Daily
0.890
ASTM D1298 / D2598
Distillation
Weekly
-
ASTM D86
Water & Sediment
Daily
ASTM D96
Salt Content
Daily
ASTM D3230
Total Sulfur Conradson Carbon Residue Pour Point
Weekly
ASTM D2622 / D2784
On Request
8.5 %wt
ASTM D189
On Request
-48 ºC
ASTM D97
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 189 of 244
SLOPS FROM STORAGE Stream
SLP-098002
Service Description
SLOP OIL
Sample point
SC-0051
PID N°
480001
Analysis Performed
Frequency
Value
Test Method
Specific Gravity (15ºC)
On Request
Distillation
On Request
Water & Sediment
On Request
ASTM D96
Salt content
On Request
ASTM D3230
ASTM D1298 / D2598 -
ASTM D86
WILD NAPHTHA FROM HDS UNIT Stream
NPH-098001
Service Description
WILD NAPHTHA
Sample point
SC-0039
PID N°
480135
Analysis Performed
Frequency
Specific Gravity (15ºC)
On Request
Distillation
On Request
Value
Test Method ASTM D1298 / D2598
-
ASTM D86
Total Sulfur
On Request
ASTM D2622 / D2784
Water Content
On Request
ASTM D95
Reid Vapor Pressure
On Request
ASTM 323
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 190 of 244
DESALTED CRUDE FROM DESALTERS Stream
Service Description
Sample point
PID N°
CRD-007002
DESALTED CRUDE
SC-0016
480012
Analysis Performed
Frequency
Value
Test Method
Specific Gravity (15ºC)
Daily
ASTM D1298 or ASTM D4052
Water & Sediment
Daily
ASTM D96
Salt content
Daily
ASTM D3230
NAPHTHA TO NHDT Stream
NPH-021002
Service Description
Naphtha
Sample point
SC-0007
PID N°
480051
Analysis Performed
Frequency
Value
Test Method
Specific Gravity (15ºC)
Daily
0.675
ASTM D1298 / D2598
Distillation
Daily
-
ASTM D86
TBP Cut Range
Weekly
IP – 145 ºC
ASTM D2892
Composition
Weekly
Total Sulfur
Weekly
62 ppm wt
ASTM D2622 / D2784
UOP 539 or IFP 9301
Total Nitrogen
On Request
< 1 ppm wt
ASTM D4629
PONA
On Request
-
ASTM D1319
Water Content
Weekly
500 ppm wt
ASTM D95
Reid Vapor Pressure
On Request
1.5 bara
Color
On request
ASTM 323 ASTM D156 or D1500
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 191 of 244
KEROSENE PRODUCT Stream
KER-025002
Service Description
Kerosene
Sample point
SC-0019
PID N°
480058
Analysis Performed
Frequency
Value
Test Method
Specific Gravity (15ºC)
Daily
0.783
ASTM D1298 / D2598
Distillation
Daily
FBP ≤ 300°C
ASTM D86
TBP Cut Range
Weekly
145 – 230 ºC
ASTM D2892
Total Sulfur
On request
0.2 %wt
ASTM D2622 / D2784
Total Nitrogen
On request
1 ppm wt
ASTM D4629
Smoke Point
On request
26 mm
ASTM D1322
Freezing Point
On request
-52 ºC
ASTM D2386
Flash Point
On request
40 ºC
ASTM D93 / D92
Water content Cetane Number (motor) Cetane Index (calculated) Kinematic viscosity @ 50°C Copper Corrosion
On request
< 1 ppm wt
ASTM D95
On request
52
ASTM D613
On request
50
ASTM D4737
On request
1 cSt
ASTM D445
On request
ASTM D130
Total Acid
On request
ASTM D664
Color
On request
ASTM D156 or D1500
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 192 of 244
LAGO PRODUCT Stream
LGO-025002
Service Description
LAGO
Sample point
SC-0003
PID N°
480051
Analysis Performed
Frequency
Value
Test Method
Specific Gravity (15°C)
Daily
0.832
ASTM D2598 / D1298
Distillation
Daily
-
ASTM D86
TBP Cut range
Weekly
200 -300 ºC
ASTM D2892
Total Sulfur
On Request
1 %wt
ASTM D2622 / D2784
Total Nitrogen
On Request
16 ppm wt
ASTM D4629
Cloud Point
On Request
-18 ºC
ASTM D2500
Pour Point Flash Point PenskyMartens Water content Cetane Number (motor) Cetane Index (calculated) Kinematic Viscosity @ 50ºC Color
On Request
-18 ºC
ASTM D97
On Request
92 ºC
ASTM D93
On Request
2000 ppm wt
ASTM D95
On Request
60
ASTM D613
On Request
55
ASTM D4737
On Request
2 cSt
ASTM D445
Daily
ASTM D156 or D1500
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 193 of 244
HAGO PRODUCT Stream
HGO-025002
Service Description
HAGO
Sample point
SC-0020
PID N°
480062
Analysis Performed
Frequency
Value
Test Method
Specific Gravity (15°C)
Daily
0.874
ASTM D2598 / D1298
TBP Cut range
Weekly
300 – 360 ºC
ASTM D2892
Distillation
Daily
-
ASTM D86
Total Sulfur
On Request
2 %wt
ASTM D2622 / D2784
Total Nitrogen
On Request
145 ppm wt
ASTM D4629
Cloud Point
On Request
-1 ºC
ASTM D2500
Pour Point Flash Point PenskyMartens Water content Cetane Number (motor) Cetane Index (calculated) Viscosity @ 50°C
On Request
-3 ºC
ASTM D97
On Request
123 ºC
ASTM D93
On Request
1500 ppm wt
ASTM D95
On Request
59
ASTM D613
On Request
55
ASTM D4737
On Request
5.0
ASTM D445
Color
Daily
ASTM D156 or D1500
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 194 of 244
ATMOSPHERIC RESIDUE TO VDU Stream
RES-027003
Service Description
Atm Residue
Sample point
SC-0043
PID N°
480066
Analysis Performed
Frequency
Value
Test Method
Specific Gravity (15ºC)
Daily
ASTM D2598 / D1298
Distillation
Weekly
ASTM D86 / D1160
TBP Cut range
Weekly
ASTM D2892
Flash point
Weekly
ASTM D93
Pour Point
On Request
ASTM D97
Total Sulfur
On Request
ASTM D2622 / D2784
Viscosity @ 100ºC Conradson Carbon Residue Metal Content (Ni+V)
On request
ASTM D445
Weekly
ASTM D189 or D4530
Weekly
ASTM D5863
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 195 of 244
LVGO PRODUCT Stream
LGO-037007
Service Description
LVGO
Sample point
SC-0002
PID N°
480098
Analysis Performed
Frequency
Value
Test Method
Specific Gravity (15°C)
Daily
0.878
ASTM D2598 / D1298
Distillation
Daily
-
ASTM D86
Viscosity @ 50ºC
On request
5 cSt
ASTM D445
TBP Cut Range
Weekly
360 - 379 ºC
ASTM D2892
Total Sulfur
On Request
2 %wt
ASTM D2622 / D2784
Total Nitrogen
On Request
176 ppm wt
ASTM D4629
Cloud Point
On Request
0 ºC
ASTM D2500
Pour Point Flash Point PenskyMartens Water content Cetane Number (motor) Cetane Index (calculated)
On Request
-2 ºC
ASTM D97
On Request
121 ºC
ASTM D93
On Request
150 ppm wt
ASTM D95
On Request
56
ASTM D613
On Request
53
ASTM D4737
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 196 of 244
MVGO PRODUCT Stream
Service Description
Sample point
PID N°
HGO-038003
MVGO
SC-0046
480099
Stream
Service Description
Analysis Performed
Frequency
Value
Test Method
Specific Gravity (15°C)
Daily
0.920
ASTM D2598 / D1298
Distillation
Daily
-
ASTM D1160
Frequency
Value
Test Method
Specific Gravity (15°C)
Daily
0.938
ASTM D2598 / D1298
Distillation
Weekly
-
ASTM D1160
Viscosity @ 100ºC
On request
11 cSt
ASTM D445
TBP Cut Range
Weekly
379 – 550 ºC
ASTM D2892 or D7169
MVGO + HVGO PRODUCT
HGO-008001
HVGO
Sample point
SC-0008
PID N°
480100
Analysis Performed
Total Sulfur
On Request
3.15 %wt
ASTM D2622 / D2784
Total Nitrogen Conradson Carbon Residue Asphaltens C7
On Request
1035 ppm wt
ASTM D4629
Weekly
0.9 %wt
ASTM D189
On Request
148 ppm wt
IP143
Metal Content (Ni+V)
Weekly
1.9 ppm wt
ASTM D5863
Color
Daily
ASTM D156 or D1500
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 197 of 244
VACUUM RESIDUE PRODUCT Stream
RES-010003
Service Description
Vacuum Residue
Sample point
SC-0023
PID N°
480104
Analysis Performed
Frequency
Value
Test Method
Specific Gravity (15°C)
Daily
1.054
ASTM D2598 / D1298
Distillation
Weekly
-
ASTM D1160
Viscosity @ 100ºC
On request
21500 cSt
ASTM D445
TBP Cut Range
Weekly
550+ ºC
ASTM D2892 or D7169
Total Sulfur
On Request
5 %wt
ASTM D2622 / D2784
Flash Point Conradson Carbon Residue Asphaltens C7
Daily
On Request
22 ppm wt
IP143
Metal Content (Ni+V)
Weekly
158 ppm wt
ASTM D5863
Aniline Point
On Request
14 ºC
ASTM D611
Value
Test Method
Weekly
ASTM D93 27 %wt
ASTM D189
OFF-GAS TO F-0002 Stream
Service Description
Sample point
PID N°
Analysis Performed H2S
Weekly
UOP 539
VTG-036003
OFF-GAS
SC-0030
480094
Oxygen
Weekly
UOP 539
Gas Chromatography
Weekly
UOP 539
Frequency
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 198 of 244
SOUR WATER FROM D-0003 Stream
SRW-012001
Service Description
SOUR WATER
Sample point
SC-0027
PID N°
480023
Analysis Performed
Frequency
Value
Test Method
pH
Daily
ASTM D1293
Chlorides
Weekly
ASTM D512
Iron
Weekly
UOP 314 / ASTM D1068
H2S
On Request
ASTM D4658
NH3 Content
On Request
ASTM D1426
Oil Content
On Request
ASTM D3921
SOUR WATER FROM D-0004 Stream
SRW-019001
Service Description
SOUR WATER
Sample Point
SC-0028
PID N°
480046
Analysis Performed
Frequency
Value
Test Method
pH
Daily
ASTM D1293
Chlorides
Weekly
ASTM D512
Iron
Weekly
UOP 314 / ASTM D1068
H2S
On Request
ASTM D4658
NH3 Content
On Request
ASTM D1426
Oil Content
On Request
ASTM D3921
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 199 of 244
SOUR WATER FROM D-0005 Stream
SRW-021001
Service Description
SOUR WATER
Sample Point
SC-0029
PID N°
480050
Analysis Performed
Frequency
Value
Test Method
pH
Daily
ASTM D1293
Chlorides
Weekly
ASTM D512
Iron
Weekly
UOP 314 / ASTM D1068
H2S
On Request
ASTM D4658
NH3 Content
On Request
ASTM D1426
Oil Content
On Request
ASTM D3921
SOUR WATER FROM D-0006 Stream
SRW-044002
Service Description
SOUR WATER
Sample Point
SC-0004
PID N°
480114
Analysis Performed
Frequency
Value
Test Method
pH
Daily
ASTM D1293
Chlorides
Weekly
ASTM D512
Iron
Weekly
UOP 314 / ASTM D1068
H2S
On Request
ASTM D4658
NH3 Content
On Request
ASTM D1426
Oil Content
On Request
ASTM D3921
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 200 of 244
STEAM GENERATOR BLOWDOWN Stream
BRN-042003
Service Description
BFW
Sample Point
SC-0022
PID N°
480105
Analysis Performed
Frequency
Value
Test Method
pH
Weekly
ASTM D1293
Conductivity
Weekly
ASTM D1125
Hardness
Weekly
ASTM D1126
Chlorides
Weekly
ASTM D0512
WATER EFFLUENT TO BL Stream
BRN-042003
Service Description
BRINE
Sample Point
SC-0005
PID N°
480109
Analysis Performed
Frequency
Value
Test Method
pH
Weekly
Total Suspend Solids
Weekly
Chlorides
Weekly
ASTM D1293 ASTM D5907 ASTM D0512
Iron
Weekly
UOP 314 / ASTM D1068
Oil Content
Weekly
ASTM D3921
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 201 of 244
X.2. Analyzers Analyzer AT-0001 AT-0002 AT-0003 AT-0004 AT-0005 AT-0006 AT-0007 AT-0011 AT-0012 AT-0013 AT-0015
Stream F-0001 FLUE GAS (CELL 1) F-0001 FLUE GAS (CELL 2) F-0001/F-0002 FLUE GAS F-0001/F-0002 FLUE GAS F-0001/F-0002 FLUE GAS F-0002 FLUE GAS (CELL 1) F-0002 FLUE GAS (CELL 2) KEROSENE RUNDOWN LVGO RUNDOWN NAPHTHA RUNDOWN VAC RESIDUE RUNDOWN
Sample point for validation
Recommended Test Method
CONNECTION ON STACK CONNECTION ON STACK CONNECTION ON STACK CONNECTION ON STACK CONNECTION ON STACK CONNECTION ON STACK CONNECTION ON STACK
“ORSAT” APPARATUS “ORSAT” APPARATUS
CONTINUOUSLY
SC-0019
ASTM D93
Weekly
CLOUD POINT
4 – 8 min
SC-0002
ASTM D2500
Weekly
480051
ASTM D86 95%
35 – 45 min
SC-0007
ASTM D86
Weekly
480051
VISCOSITY @150ºC
3 min
SC-0023
ASTM D445
Weekly
PID N°
Analysis Performed
Frequency of results
480117
%O2
480117
%O2
480121
%SO2
4 sec @ 60 l/h
480121
%O2
< 4 sec @ 60 l/h
480121
OPACITY
480120
%O2
480120
%O2
480058
FLASH POINT
480098
Frequency for Validation On Request On Request On Request
“ORSAT” APPARATUS
On Request On Request
“ORSAT” APPARATUS “ORSAT” APPARATUS
On Request On Request
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 202 of 244
Analyzer AT-0017 AT-0018 AT-0019 AT-0020 AT-0021 AT-0022 AT-0024 AT-0025 AT-0026 AT-0032 AT-0033 AT-0034 AT-0035 AT-0036 AT-0040
Stream SOUR WATER FROM D-0008 DESALTING WATER SOUR WATER FROM D-0004 SOUR WATER FROM D-0005 SOUR WATER FROM D-0003 KEROSENE RUNDOWN KEROSENE RUNDOWN LAGO RUNDOWN HAGO RUNDOWN PREFLASH NAPHTHA REFLUX CDU OVERHEAD CDU NAPHTHA REFLUX VDU OVERHEAD PREFLASH OVERHEAD CARTRIDGE FILTER
PID N°
Analysis Performed
Frequency of results
Sample point for validation
Recommended Test Method
Frequency for Validation
480088
pH
CONTINUOUSLY
SC-0021
ASTM D1293
Weekly
480111
pH
CONTINUOUSLY
SC-0014
ASTM D1293
Weekly
480046
pH
CONTINUOUSLY
SC-0028
ASTM D1293
Weekly
480050
pH
CONTINUOUSLY
SC-0029
ASTM D1293
Weekly
480023
pH
CONTINUOUSLY
SC-0027
ASTM D1293
Weekly
480058
ASTM D86 95%
35 – 45 min
SC-0019
ASTM D86
Weekly
480058
FREEZING POINT
8 – 20 min
SC-0019
ASTM D2386
Weekly
480060
ASTM D86 95%
35 – 45 min
SC-0003
ASTM D86
Weekly
480062
ASTM D86 95%
35 – 45 min
SC-0020
ASTM D86
Weekly
480022
CORROSION
CONTINUOUSLY
-
480043
CORROSION
CONTINUOUSLY
-
480047
CORROSION
CONTINUOUSLY
-
480082
CORROSION
CONTINUOUSLY
-
480020
CORROSION
CONTINUOUSLY
-
480270
RELATIVE HUMIDITY
CONTINUOUSLY
-
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 203 of 244
Analyzer
Stream
PID N°
Analysis Performed
Frequency of results
Sample point for validation
480270
HC CONTENT
CONTINUOUSLY
-
INLET (S-0013A-D) AT-0045A/B
SANDY AIR INLET (AMBIENT)
Recommended Test Method
Frequency for Validation
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 204 of 244
X.3. Sample Connections for Monitoring In case of upset condition or for monitoring some streams, the following sample connections are also provided for analysis as required: Service
Sample connection
P&ID
NAPHTHA REFLUX
SC-0006
DS011-TRJR-480047
D-0001 DESALTER TRYCOK
SC-0009
DS011-TRJR-480011
D-0002 DESALTER TRYCOK
SC-0010
DS011-TRJR-480012
FUEL GAS KO DRUM TO HEATER
SC-0012
DS011-TRJR-480214
DESALTING WATER TO E-0024
SC-0014
DS011-TRJR-480110
CRUDE FROM D-0001 DESALTER
SC-0015
DS011-TRJR-480011
DESALTER BRINE FROM D-0001
SC-0017
DS011-TRJR-480011
DESALTER WATER FROM D-0002
SC-0018
DS011-TRJR-480013
SOUR WATER FROM D-0008
SC-0021
DS011-TRJR-480088
SATURED STEAM FROM D-0011
SC-0024
DS011-TRJR-480105
SOUR OFF GAS FROM K-0001
SC-0025
DS011-TRJR-480091
RECOVERED OIL FROM D-0008
SC-0026
DS011-TRJR-480087
RICH AMINE FROM C-0007
SC-0031
DS011-TRJR-480095
NAPHTHA VAPOR FROM D-0003
SC-0040
DS011-TRJR-480023
FLUE GAS ON F-0001 (CELL 1) FLUE GAS ON F-0001 (CELL 2) FLUE GAS ON F-0002 (CELL 1) FLUE GAS ON F-0002 (CELL 2) F-0001 FLUE GAS F-0002 FLUE GAS
CONNECTION ON STACK CONNECTION ON STACK CONNECTION ON STACK CONNECTION ON STACK CONNECTION ON STACK CONNECTION ON STACK
DS011-TRJR-480117 DS011-TRJR-480117 DS011-TRJR-480120 DS011-TRJR-480120 DS011-TRJR-480117 DS011-TRJR-480120
LEAN AMINE FROM BL
SC-0044
DS011-TRJR-480094
SOUR WATER FROM D-0017
SC-0045
DS011-TRJR-480093
COOLING WATER RETURN AT BL
SC-0047
DS011-TRJR-480207
AMINE DRAIN
SC-0048
DS011-TRJR-480233
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 205 of 244
Service
Sample connection
P&ID
BFW FROM DISTRIBUTION
SC-0049
DS011-TRJR-480202
CONDENSATE TO BL
SC-0050
DS011-TRJR-480201
CRUDE TO D-0001 DESALTER
SC-0061
DS011-TRJR-480011
CRUDE TO D-0002 DESALTER
SC-0062
DS011-TRJR-480012
TEMPERED WATER
SC-0063
DS011-TRJR-480124
XI. PLANT SAFETY AND ENVIRONMENTAL PROTECTION XI.1. Toxic Hazards According to Project Standards JERES-B-006 and 2271-JSD-0001-03, a toxic material is a liquid, gas or solid with a total concentration of 5 % or greater of material with an NFPA 704 Health rating of “3” or greater or classified as Toxic (or extremely toxic), only for acute toxicity, in the relevant Material Safety Data Sheet at any operating condition. For the particular cases of mixture containing H2S and / or CO, such mixture shall be considered as toxic based on the criteria published by European Directive 1999/45/EC of the European Parliament and of the Council (31st May 1999), as presented in Table XI.1. Mixture Classification Pure Substance
Non Gaseous Mixture
Gaseous Mixture
(Concentration weight/weight)
(Concentration volume/volume)
H2S
Toxic if concentration ≥ 1%
Toxic if concentration ≥ 0.2%
CO
Toxic if concentration ≥ 25%
Toxic if concentration ≥ 5%
XI.1-1: H2S and CO Toxic Criteria
During detailed engineering, a list of Hazardous substances CDU/VDU Unit Crude Distillation Unit Train 1 Unit 011 Doc. No. SA-JER-DS011-TRJR-670008 was developed. Once, their composition was reviewed, it was concluded that following streams pose toxic risk as per the project toxic criteria: •
Sour water (1,830 % mol H2S).
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 206 of 244
•
VDU Off Gas (0,272 % mol H2S).
•
Sour Off Gas (18,236 % mol H2S).
•
Rich amine (2,100 % mol H2S).
Toxic services have been marked up in the Process Flow Diagrams attached to Pollutant and Toxic map (Units 011 and 012) Doc. No. SA-JER-DS011-TRJR-581512 and identified in the Line list Crude Distillation Unit Train 1 (Unit 011) Doc. No. SA-JERDS011-TRJR-380001. Information such as form, concentration and container type of chemicals used in Unit 091 can be found in Chemical Consumption Summary CDU/VDU Unit (Unit 011) Doc. No. SA-JER-DS011-TRJR-670003. Equipments which handle hydrogen sulfide are identified in the Fire Hazardous Equipment and Ignition Point List Doc. No. SA-JER-DS011-TRJR-385803. The following safety equipment shall be provided, based on toxicity hazards: •
Portable gas detectors including calibration check kits for measuring the concentration of hydrogen sulfide in the air.
•
Personal dosimeters for hydrogen sulfide, 8 hours duration.
•
Respiratory Protection.
Location of Hydrogen sulfide detectors is shown in F&G detection layout Doc. No. SAJER-DS011-TRJR-345803 and their data are in F&G detectors data sheets CDU-Train 1 (Unit 011) Doc. No. SA-JER-DS011-TRJR-225033. Consequences due to the toxicity hazard were reviewed in the Technological Risk Assessment Critical Scenarios (Units 011 and 012) Report Doc. No. SA-JER-DS011TRJR-581510 and Technological Risk Assessment Update (Units 011 and 012) Report Doc. No. SA-JER-DS011-TRJR-581511. No additional mitigation measures are needed as result of these modellisations.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
XI.2. Fire Hazards
XI.2.1. General Information about Flammable Theory
XI.2.1.1. Reference NFPA Fire Protection Guide to Hazardous Materials • Flash Point •
LEL/UEL
•
Specific Gravity
•
Vapor Density
•
Hazard Identification
•
Health/Flammability/Instability
NIOSH Pocket Guide To Chemical Hazards
TR Project No.: 02020 Page 207 of 244
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 208 of 244
•
Chemical Name/Formulas
•
Exposure limits (TWA)
•
IDLH
•
Physical Description
•
Chemical and physical properties
•
Incompatibilities and reactivities
•
Health hazards
ACGIH, Threshold Limit Values for Chemical Substances and Physical Agents & Biological Exposure Indices • Substance (CAS number) •
TWA
•
STEL
•
Molecular Weight
•
TLV Basics-Critical Effects
XI.2.1.2. Definitions Flash Point: Temperature at which the liquid phase gives off enough vapor to flash when exposed to an external ignition source. Fire Point: When a liquid is heated past its flash point it will reach a temperature where sufficient vapor is given off to maintain combustion. Ignition Point: The minimum temperature at which a substance will burn or ignite independent of an external heat source. Lower Explosive Limit (LEL): •
Also known as Lower Flammable Limit (LFL)
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 209 of 244
•
Minimum concentration of gas or vapor mixed with air that will cause the propagation of flame when it comes in contact with a source of ignition (spark or flame).
•
Concentrations of gas below the LEL are too lean to ignite.
Upper Explosive Limit (UEL): •
Maximum concentration of gas or vapor in air that will cause the propagation of flame when is exposed to a source of ignition (flame or spark).
•
Mixtures are considered to RICH to support combustion if they are above the UEL.
Pyrolysis: •
Thermochemical decomposition of organic material at elevated temperatures without the participation of oxygen. It involves the simultaneous change of chemical composition and physical phase, and is irreversible. The word is coined from the Greek-derived elements pyr "fire" and lysis "separating".
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 210 of 244
Explosive Range: •
Explosive range is different depending on the gas or vapor
•
As the fuel increases, oxygen decreases to the point where there is no longer a potential for explosion thus reaching the UEL
XI.2.1.3. Basics Fire • • • • • •
Fire is a chemical reaction exothermic oxidation and self-supporting. The oxidant is usually oxygen. Fuels may be solids, liquids or gases, but all fuels have to be vapor or gas to burn. Liquid fuels are vaporized before burning. The solids are decomposed by heat (pyrolysis) before burning By applying sufficient activation energy for oxygen
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
•
fuel mixture start the fire. In the fires with flame precise chemical chain reaction within the flame.
XI.2.1.4. Oxygen • • •
• •
In the chemical reaction of fire, the combustion fuel oxidizes. The speed of combustion is directly proportional to the amount of oxidant available. In an enclosed area with poor ventilation, combustion decreases the available oxygen, and fire can even turn off. The increase of oxygen in the atmosphere combustion. Some products easily releases oxygen in a fire. The fire may burn more intensely in the presence of these oxidizing products.
XI.2.1.5. Ignition Source •
• •
To start the fire must apply sufficient activation energy to the mixture of fuel and oxidizer. Heat is produced by the increased molecular motion. Heat can be chemical, electrical, mechanical, nuclear or solar.
TR Project No.: 02020 Page 211 of 244
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 212 of 244
XI.2.1.6. Fuel •
The fuel may be in the three states of matter: solid, liquid or gas. Solids and liquids are transformed into gas or vapor to burn. Pyrolysis is the decomposition of solids by heat, producing gases and vapors. The liquids must vaporize to burn. At the temperature of ignition, the fire goes out if you remove the ignition source. In the flash fire is maintained by removing the flame. When the fuel reaches the ignition temperature is not accurate external source of ignition for flammable.
• • • • •
XI.2.1.7. Heat Transfer •
The heat from the fire allowed continuing heating fuel and other fuels to heat up next.
•
Heat can be transmitted from one point to another in three ways: by conduction, by radiation and convection.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 213 of 244
XI.2.1.8. Heat Transfer by Conduction •
When two bodies at different temperatures are brought into contact, there is a transfer of heat from warmer to colder this phenomenon is called conduction.
•
Driving faster the better conductors of heat are the bodies. The high-density materials conduct heat faster than low density.
XI.2.1.9. Heat Transfer by Radiation •
Radiation is the transfer of heat from a hot source to a cooler surface, through space.
•
The heat transfer rate depends largely on the distance between the radiation source and the target. The amount of heat released by radiation depends on the temperature of the fire, so that will be greater the more vivid is the combustion.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 214 of 244
XI.2.1.10.Convection Heat Transfer •
The air heated by the fire expands and becomes lighter than the surrounding air and rises, warming the objects in its path.
•
This propagation of heat by air currents is called convection.
•
Convection plays the most important gases moving from fire to fire in buildings, as this may spread the fire, or hot and toxic gases are causing most of the victims.
XI.2.1.11.Heat Release Rate by a Fuel •
The growth rate of a fire in an enclosure, and the possibility of spread depends on the heat release rate and the amount of energy stored in the fuel (fire load).
•
The rate of release of heat (Heat Release Rate or HRR) is measured in kilowatts or joules / second released at a certain time of the fire, and is proportional to the mass loss rate of fuel and its heat of combustion.
•
The fire load is measured by the mass of fuel equal to that of wood.
XI.2.1.12. Classification of Fires Fires are classified according to different criteria: • The type of combustion process (everyone can co-exist) o Pre-combustion: fuel is warming o Flameless surface combustion o Flaming combustion •
The level of fire growth o Increasing: the vapor release rate exceeds the combustion o Stable: there is a balance between fuel and oxidizer o Descending: the burn rate exceeds the vapor release
•
Ventilation or oxygen availability
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 215 of 244
o Fuel dependent: there is more oxygen than fuel vapors o Dependent ventilation has more available oxygen fuel •
The stage at which is o Incipient: To produce the first flames o Stable: While there are gas flames burn freely because o Latent: There are too many for the available oxygen gases, and stop calling
It should be graded according to different parameters fires so you can identify what type of fire we speak, what their characteristics and what is the stage that is. XI.2.1.13. Theory of Fire Extinguishing •
The extinction of fire occurs or eliminating one or more of the essential elements in the combustion process.
•
If a fire is in sleep mode or embers, there are only three options extinguishing media: temperature reduction, elimination of fuel or oxygen removal.
•
In a combustion flame, the fire can be extinguished by reducing the temperature, eliminating the oxygen or fuel, or stop chemical chain reaction.
XI.2.1.14. Fire Extinguishing: Reducing the Temperature •
One of the most common forms of extinction is cooling.
•
Solid fuels and some liquids must be heated until give off flammable vapors can burn.
•
Fires in these fuels, if the temperature is reduced to the level enough to vaporize the fuel and let the fire go out.
•
The fire is maintained when it is clear enough heat to maintain the process. If applied to any product that absorbs heat the heat necessary to sustain combustion, the fire goes out.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 216 of 244
XI.2.1.15. Fire Extinguishing: Fuel Separation •
Removal of fuel is the extinction of the fire. This removal of the fuel can occur for the following reasons: o Because all fuel is consumed o Because has cut the fuel supply o Because the amount of fuel vapors is not enough for the available oxygen,
•
Sometimes defensive strategies in the fight against seek to eliminate fire fuel input to fire o physically separating the fuel from oxygen o Separating unburned fuel o Leaving fuel burn
•
Fuel removal may be the only appropriate strategy in fires gas, since these fires off if you cannot cut the gas supply can a risk of explosion of the unburned gas.
XI.2.1.16. Fire Extinguishing: Dilution or Displacement of Oxygen •
Reducing the oxygen content below a certain concentration, the fire goes out.
•
The fire will go out by reducing the oxygen content: o Because flood the area with an inert gas to displace oxygen and reduce its concentration do o Because physically separates the source of fuel vapors in the atmosphere
•
Some fuels generate their own oxygen in the process of combustion, so this method does not work with extinction these fuels.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 217 of 244
XI.2.1.17.Fire Extinguishing: by Inhibiting the Chain Reaction •
Chain reaction may be interfered with by interposing a chemical that acts as a negative catalyst.
•
Eliminating chain reaction fire off completely where there is only fire.
•
This method is effective in extinguishing gases and combustible liquids. The chemical powder inhibits the chain reaction
•
Fires leave embers solid products that do not go out with this method, because from the fire may come back flames.
XI.2.1.18. Fire Extinguishing: Class •
The best method of extinguishing fires is to reduce the solids fuel temperature.
•
Liquid fires may be extinguished: o By breaking the chain reaction. o From suffocation by displacing oxygen with another gas. o Isolating the fuel liquid oxygen. o Cooling.
•
Flammable gas fires can be extinguished like the liquids. However, in liquids is not suitable to extinguish because the liquids. However, without inflaming leak can cause an explosion.
•
Combustible metal fires require extinguishing agents those specific covering the burning metal.
XI.2.1.19. Fire Extinguishing Agents Common extinguishing agents are: • water, which can be used mixed with additives to improve their effectiveness •
Carbon dioxide or CO2
•
DUST NORMAL or BC,
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 218 of 244
•
multipurpose powder, antibrasa or ABC
•
foam, which is produced by mixing water with foam additives and with air bubbles,
•
other gases, which can be of various types o Inerting
Argon
Argonite 50% mixture of nitrogen and argon
Inergen nitrogen and argon and CO2
o Inhibitors chain reaction (halocarbon)
FE-13
FM-200
FE-25
Novec 1230
Etc.
XI.2.2. List of Flammable Limits, Self Ignition Temperature and Flash Point streams and Chemicals present in the Unit
FLASH POINT
FLAMMABILITY LIMITS
VOLATILITY RELATIVE DENSITY
IGNITION TEMP.
30-177
>1
290
0.0877
>150
>1
>232
7.6
0.3211
30-177
>1
290
0.9
7.6
0.3507
30-177
>1
290
-82
0.9
7.6
1.368
30-177
>1
290
NA
NA
NA
0.02341
≈100
>1
NA
LOWER (LFL)
UPPER (UFL)
VAPOUR PRES.
BOILING POINT
(ºC)
(% Vol)
(% Vol)
(Bara)
(ºC)
FRESH CRUDE
-15
0.4
15.0
0.456
>-14
DESALTED CRUDE
-15
0.4
15.0
0.48
>-14
NAPHTA
-35
0.9
7.6
0.294
TOPPED CRUDE
20
0.4
15.0
TOTAL NAPHTA
-67
0.9
HEAVY NAPHTHA
-35
WET NAPHTA SOUR WATER
NAME
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 219 of 244
FLASH POINT
FLAMMABILITY LIMITS
VOLATILITY RELATIVE DENSITY
IGNITION TEMP.
145-301
>1
210
0.0238
230-300
>1
>250
6.5
0.02347
300-360
>1
>250
0.5
6.5
0.03759
379-550
>1
210270
SWEET OFF-GAS
-90
4.8
32.5
133
1
270
FUEL GAS
-60
3.8-6.5
13-17
>300
-162
>1
372
DESALTING WATER
NA
NA
NA
0.02341
≈100
>1
NA
PILOT GAS
-104
1.4
11
8.1
-42
>1
NA
RICH AMINE
NA
NA
NA
0.02341
≈100
>1
NA
LEAN AMINE
NA
NA
NA
0.02341
≈100
>1
NA
FLUE GAS
NA
NA
NA
>50
1
-
DEMULSIFIER
>58
(5)
(5)
1
>450
Non combustible
NA
NA
≈0
-
>1
None
NEUTRALIZING AGENT CORROSION INHIBITOR PHOSPHATE
For more details refer to Attachment 20 – List of Hazardous Substances.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 220 of 244
XI.2.3. General HSE Precautions to avoid the Flammable Conditions
Once, it is not possible to avoid completely the explosive atmospheres formation, the next step shall be implement the preventive measures to avoid ignition sources presence. Ignition sources of typical importance and normally considered in refinery units from EN-1127-1 Explosive atmospheres- Explosion prevention and protection Part 1, Basic Concepts and Methodology, are: •
Hot surfaces.
•
Flames, Glowing particles and Sparks.
•
Mechanical Sparks.
•
Electric devices (discharge sparks, hot surfaces).
•
Stray electric current.
•
Lightning.
•
Electromagnetic waves.
•
Ionizing radiation.
•
Ultrasound.
•
Adiabatic compression and shock waves.
•
Exothermic reactions.
An Explosion Risk Area Classification Assessment (ERACA) for CDU/VDU Unit, Doc. No. SA-JER-DS011-TRJR-581513 was developed on the basis of the hazardous area classification drawings, in order to verify that ignition sources capable to ignite explosive atmosphere are controlled. This control can be the proper equipment selection or the adoption of adequate measures to reduce the ignition risk to acceptable levels. The risk analysis was performed taking into account the ignition risk in normal conditions, and also in cases of foreseable malfunction.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 221 of 244
ERACA report concluded that all equipment and instruments of Units 011 and 012 have been adequately selected according the Hazardous Area Classification Drawing, once their certificates were reviewed. A total of nine (9) recommendations were recorded as a result of this Study. Num. 1 2
3
4 5
6 7 8 9
Recommendation Ensure the use of antistatic clothes and shoes in the whole unit to avoid static electricity formation in Hazardous Classified Areas. Ensure the use of Antisparks Tools in the whole unit to avoid mechanical sparks in Hazardous Classified Areas. Ensure that mobile devices and equipment are certificated to be used in Hazardous Classified areas to avoid the formation of ignition sources (hot surfaces, ultrasonics, electromagnetic waves, ionizing radiation, etc.). Ensure that signs warning about Explosive Hazards are located around the whole unit. Ensure that there are placed warning signs forbidding smoking out of the allowed areas and restricting the use of matches and lighters. Ensure that Company provides a proper access control for workers, visitors, vehicles to the unit in order to control potential ignition sources formation in hazardous classified areas.
Type Technical Technical
Technical
Organizational Organizational
Organizational
Ensure that all workers are trained in Hazardous Classified areas.
Organizational
Ensure that Company provides a proper work permit system to avoid ignition source. Ensure that maintenance procedures are developed taking into account the Hazardous Area Classification in order to avoid dangerous operations in these areas.
Organizational Organizational
XI.2-1: Summary of the recommendations recorded in the ERACA report for CDU/VDU
As general prevention measures, it will be considered staff training, work permits and maintenance of equipment and instrumentation. ERACA Report also identified specific preventive measures for each ignition source within the EN-1127-1. (Refer to section 4.4.2 of SA-JER-DS011-TRJR-581513). In order to mitigate the consequences of a flammable release within CDU/VDU Units (011 and 012), combustible, hydrogen and hydrogen sulfide detectors are implemented, as well as fire water monitors and water curtain. Location is shown in:
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 222 of 244
•
F&G detection layout Doc. No. SA-JER-DS111-TRJR-345803.
•
Fire Protection layout Doc. No. SA-JER-DS111-TRJR-345802.
A Technological Risk Assessment (TRA) Report Doc. No. SA-JER-DS011-TRJR581511 is also carried out for CDU/VDU Units (011 and 012). Effects were ranked within the level 3 risk region, therefore, no additional measures are proposed.
XI.2.4. List of Fire Scenarios
Refer to document SA-JER-DS011-TRJR-345801, Attachment 21 – Fire Hazard envelope Layout.
XI.2.5. List of Specific Flame, Leak, Heat or Gas Detectors and Relative Control Systems or Fire Fighting Systems Provided, If Any. Key Tag 011-GDF-0001 011-GDF-0002 011-GDF-0003 011-GDF-0004 011-GDF-0005 011-GDF-0006 011-GDF-0007 011-GDF-0008 011-GDF-0009 011-GDF-0010 011-GDF-0011 011-GDF-0012 011-GDF-0013 011-GDF-0014 011-GDF-0015 011-GDF-0016 011-GDF-0017 011-GDF-0018 011-GDF-0019 011-GDF-0020 011-GDF-0021
Instrument Type Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
Key Tag 011-GDF-0022 011-GDF-0023 011-GDF-0024 011-GDF-0025 011-GDF-0026 011-GDF-0027 011-GDF-0028 011-GDF-0029 011-GDF-0030 011-GDF-0031 011-GDF-0032 011-GDF-0033 011-GDF-0034 011-GDF-0035 011-GDF-0036 011-GDF-0037 011-GDF-0038 011-GDF-0039 011-GDF-0040 011-GDF-0041 011-GDF-0042 011-GDF-0043 011-GDF-0044 011-GDF-0045 011-GDF-0046 011-GDF-0047 011-GDF-0048 011-GDF-0201 011-GDF-0801 011-GDF-0802 011-GDF-0803 011-GDF-0804 011-GDF-0805 011-GDF-0806 011-GDF-0807 011-GDF-0808 011-GDF-0809 011-GDF-0850 011-GDF-0851 011-GDF-0852 011-GDF-0853 011-GDF-0855 011-GDF-0856
Instrument Type Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector Combustible Gas Detector
TR Project No.: 02020 Page 223 of 244
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
Key Tag 011-DFHXS-0601-L 011-DFHXS-0602-L 011-DFHXS-0603-L 011-DFHXS-0604-L 011-DFHXS-0605-L 011-DFHXS-0606-L 011-DFHXS-0607-L 011-HXS-0481 011-HXS-0482 011-HXS-0483 011-HXS-0484 011-HXS-0485 011-HXS-0486 011-HXS-0487 011-HXS-0488 011-HXS-0489 011-HXS-0490 011-HXS-0491 011-HXS-0494 011-HXS-0495 011-HXS-0496 011-HXS-0497
Instrument Type Deluge Release Deluge Release Deluge Release Deluge Release Deluge Release Deluge Release Deluge Release Manual Call Point Manual Call Point Manual Call Point Manual Call Point Manual Call Point Manual Call Point Manual Call Point Manual Call Point Manual Call Point Manual Call Point Manual Call Point Manual Call Point Manual Call Point Manual Call Point Manual Call Point
Key Tag 011-GFAA-0409 011-GFAA-0410 011-GFAA-0411 011-GFAA-0412 011-GFAA-0413 011-GFAA-0414 011-GFAA-0415 011-GFAA-0445 011-GFAA-0840 011-GFAA-0841 011-GFAA-0844 011-GFAB-0051 011-GFAB-0052 011-GFAB-0053 011-GFAB-0054 011-GFAB-0055 011-GFAB-0056 011-GFAB-0057 011-GFAB-0058 011-GFAB-0059
Instrument Type Audible Alarm Audible Alarm Audible Alarm Audible Alarm Audible Alarm Audible Alarm Audible Alarm Audible Alarm Audible Alarm Audible Alarm Audible Alarm Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon
TR Project No.: 02020 Page 224 of 244
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
Key Tag 011-GFAB-0060 011-GFAB-0061 011-GFAB-0062 011-GFAB-0063 011-GFAB-0064 011-GFAB-0065 011-GFAB-0070 011-GFAB-0251 011-GFAB-0252 011-GFAB-0253 011-GFAB-0254 011-GFAB-0255 011-GFAB-0256 011-GFAB-0257 011-GFAB-0258 011-GFAB-0259 011-GFAB-0260 011-GFAB-0509 011-GFAB-0510 011-GFAB-0511 011-GFAB-0512 011-GFAB-0513 011-GFAB-0514 011-GFAB-0515 011-GFAB-0830 011-GFAB-0831 011-GFAB-0838
Instrument Type Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon
Key Tag 011-UAB-0551 011-UAB-0552 011-UAB-0553 011-UAB-0554 011-UAB-0555 011-UAB-0556 011-UAB-0557 011-UAB-0558 011-UAB-0836 011-UAB-0837
Instrument Type Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon Alarm Beacon
Key Tag 011-TDL-0501 011-TDL-0502 011-TDL-0503
Instrument Type Linear Heat Detector Linear Heat Detector Linear Heat Detector
TR Project No.: 02020 Page 225 of 244
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 226 of 244
Key Tag 011-TDL-0504 011-TDL-0505 011-TDL-0506 011-TDL-0507 011-TDL-0508 011-TDL-0509 011-TDL-0510 011-TDL-0511 011-TDL-0512 011-TDL-0513 011-TDL-0514 011-TDL-0515 011-TDL-0516 011-TDL-0517 011-TDL-0518 011-TDL-0519 011-TDL-0520 011-TDL-0521 011-TDL-0522 011-TDL-0523 011-TDL-0524 011-TDL-0525 011-TDL-0526 011-TDL-0527 011-TDL-0528 011-TDL-0529 011-TDL-0533
Instrument Type Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector Linear Heat Detector
See document SA-JER-DS011-TRJR-345803, Attachment 22 – F&G Detection Layout.
XI.2.6. Number & Design of Fire Water Monitors, Lances and Hydrants. Plot plan and Coverage Area and List. Idem for Steam Lances
UNIT-011 011-MLZ- 0051 011-MLZ- 0052 011-MLZ- 0053 011-MLZ- 0054 011-MLZ- 0055
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
UNIT-011 011-MLZ- 0056 011-MLZ- 0057 011-MLZ- 0058 011-MLZ- 0059 011-MLZ- 0060 011-MLZ- 0061 011-MLZ- 0062 011-MLZ- 0063 011-MLZ- 0064 011-MLZ- 0065 011-MLZ- 0066 011-MLZ- 0067 011-MLZ- 0068 011-MLZ- 0069 011-MLZ- 0070 011-MLZ- 0071 011-MLZ- 0072 011-MLZ- 0073 011-MLZ- 0074 011-MLZ- 0075 011-MLZ- 0076 011-MLZ- 0077 011-MLZ- 0078 011-MLZ- 0079 011-MLZ- 0080 011-MLZ- 0081 011-MLZ- 0082 011-MLZ- 0083 011-MLZ- 0084 011-MLZ- 0085
TR Project No.: 02020 Page 227 of 244
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 228 of 244
See localization in document SA-JER-DS011-TRJR-345802, Attachment 23 – Fire Protection Layout.
XI.2.7. Localization and Capacity and Purpose (Electricity, Hydrocarbons, Multi Purpose) of Extinguishers (Plot plan and List)
UNIT-011 27 lb
125 lb
CO2
011-XLZ-400
011-XLZ-405
011-XLZ-456
011-XLZ-401
011-XLZ-413
011-XLZ-457
011-XLZ-402
011-XLZ-428
011-XLZ-458
011-XLZ-403
011-XLZ-453
011-XLZ-459
011-XLZ-404
011-XLZ-454
011-XLZ-460
011-XLZ-406
011-XLZ-455
011-XLZ-461
011-XLZ-407
011-XLZ-462
011-XLZ-408
011-XLZ-463
011-XLZ-409
011-XLZ-464
011-XLZ-410
011-XLZ-465
011-XLZ-411
011-XLZ-466
011-XLZ-412
011-XLZ-467
011-XLZ-414
011-XLZ-468
011-XLZ-415
011-XLZ-469
011-XLZ-416
011-XLZ-470
011-XLZ-417
011-XLZ-471
011-XLZ-418
011-XLZ-472
011-XLZ-419
011-XLZ-473
011-XLZ-420 011-XLZ-421 011-XLZ-422 011-XLZ-423 011-XLZ-424 011-XLZ-425
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 229 of 244
UNIT-011 27 lb
125 lb
CO2
011-XLZ-426 011-XLZ-427 011-XLZ-429 011-XLZ-430 011-XLZ-431 011-XLZ-432 011-XLZ-433 011-XLZ-434 011-XLZ-435 011-XLZ-436 011-XLZ-437 011-XLZ-438 011-XLZ-439 011-XLZ-440 011-XLZ-441 011-XLZ-442 011-XLZ-443 011-XLZ-444 011-XLZ-445 011-XLZ-446 011-XLZ-447 011-XLZ-448 011-XLZ-449 011-XLZ-450 011-XLZ-451 011-XLZ-452
See localization in document SA-JER-DS011-TRJR-345802, Attachment 23 – Fire Protection Layout.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 230 of 244
XI.2.8. Localization and Coverage Area of Flashing Light and Sirens (for Gas, H2S or Fire Detection)
See document SA-JER-DS011-TRJR-345803, Attachment 22 – F&G Detection Layout.
XI.3. Personal Protective Equipment The following Personal Protective Equipment (PPE) shall be provided to CDU/VDU Units Staff based on the flammable and toxic hazards. •
Eye protection. Suitable eye protection shall be provided for all employees and visitors to protect against impact, dust or radiation.
•
Foot protection. Approved safety footwear is sturdy work shoes with leather uppers and/or leather composition with steel toe caps.
•
Head protection. A safety helmet should be worn by all persons at all times in any operating plant area.
•
Body, skin and hand protection. In operations, exposed hands and skin are susceptible to physical, chemical, and radiation hazards. Personal hand and skin protection is often the only practical means of preventing injury from physical hazards (sharp or jagged edges on materials and tools), heat, vibration, corrosive or toxic chemicals and ultraviolet radiation.
•
Ear protection. There are two types of hearing protection available, the plug type and the cup (or muff) type. Selection of one of them shall be evaluated with the aim of ensuring the noise attenuation and protection.
•
Portable gas detector including calibration check kits for measuring concentration of flammable and toxic gases gases such as hydrogen or hydrogen sulfide.
•
Personal dosimeters for hydrogen sulfide, 8 hours duration.
•
Respiratory protection. Breathing air sets consisting of lightweight twin bottle self contained sets with full-facemasks, supplied in site storage boxes shall be provided and located in the Team buildings (refer to section 4.5 Fire and Gas Detection and Alarm Fire Protection for buildings Doc. No. 2271-AAA-JSD-1970-
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 231 of 244
01). One or more of the following respiratory protection devices shall be provided for the hydrogen sulfide respiratory hazards. o Oxygen inhalation apparatus, 1.5 cubic feet/minute (6 liter per minute) capacity. o Self-contained breathing apparatus (SCBA)-positive pressure demand, nominal 30 minute air supply. o Twin cartridge, air purifying respirator with cartridges approved for hydrogen sulfide. o Full face piece, air purifying respirator with cartridges approved for hydrogen sulfide. o Gas mask designed for respiratory protection approved for hydrogen sulfide. •
First aid cabinet. First aid kits shall be inspected regularly and missing, damaged, or expired items replaced.
PPEs shall meet the requirements of Project instructions, OSHA, ANSI or equivalent standards: •
JER GI 7.027 Personnel Work Platform Operations.
•
OSHA.Code of Federal Regulations 1910, 1915 and 1926.
•
ASTM D120.E1 -87. Standard Specifications For Rubber Insulating Gloves.
•
ANSI Z 41-83. Personnel Protection - Protective Footwear.
•
ANSI Z 87.1 -89. Practice for Occupational and Educational Eye and Face Protection.
•
ANSI Z 89.1 -86. Personnel Protection - Protective Headgear for Industrial Workers – Requirements.
•
BS EN 137:2006. Respiratory protective devices-self-contained open-circuit compressed air apparatus. Requirements, testing, marking.
Staff shall be instructed in the use and care of PPEs.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 232 of 244
XI.4. Emergency List and location of means of communication with control room are shown in documentations listed below: CCTV Equipment Layout, Cable routing & Grounding Points
SA-JER-DS111-TRJR-345604
PIB 05 & SS1106 CCTV Equipment Layout & Cable routing U-111. Outdoor LS, FB & P/LS Cable routing & Grounding Points U-111. Outdoor Telephones Cable routing & Grounding Points
SA-JER-DS011-TRJR-345614 SA-JER-DS111-TRJR-345602 SA-JER-DS111-TRJR-345601
PIB 05, SS1106 & US05 PA/GA & P/L cable routing
SA-JER-DS011-TRJR-345607
XI.5. Health & Environment In case of CDU/VDU (Units 011 and 012), environmental aspects relevant to the unit in the normal, abnormal and emergency circumstances, are: •
Controlled and uncontrolled emissions to atmosphere and discharges to water, are recorded in the Effluent List CDU/VDU Unit (Unit 011) Doc. No. SA-JERDS011-TRJR-670004, Pollutant and Toxic map (Units 011 and 012) Doc. No. SA-JER-DS011-TRJR-581512, Flare Load Summary Crude Distillation Unit Train 1 (Unit 011) Doc. No. SA-JER-DS011-TRJR-670005, Leak detection and Repair (Units 011 and 012) Report Doc. No. SA-JER-DS011-TRJR-581521 and Report of Stack emissions for CDU-VDU Heaters Doc. No. SA-JER-DS011DSBS-2400183.
•
Noise impact is reviewed in the Final Noise Study Doc. No. SA-JER-DSAAATRJR-581513.
Due to the technology of this unit, aspects such as waste, dust, visual impact, contamination of land and bacteriological risks related to water treatments are not relevant. Emission discharges and noise exposure are in compliance with Royal Commission Environmental Regulations Volume 1 of Royal Commission in Al-Jubail, General EHS Guidelines of Introduction of International Finance Corporation and the Environmental Social Impact Assessment carried out by SATORP during FEED Stage.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 233 of 244
XI.6. Flare XI.6.1. Applicable Scenarios CDU flare system has been sized considering the following scenarios: •
General power failure
•
Partial Power Failure
•
Pools of fire
•
Individual safety relief valve cases
XI.6.2. Sizing limit cases The CDU flare system has been designed considering the corresponding relieves for each case. Calculations of the flare network considering the different cases results in a 44” header. The sizing limit case is Partial Power Failure. Further information regarding the flow rates, temperatures, composition, backpressures, etc. can be found in Attachment 30, “Flare Load Summary - Crude Distillation Unit”
DOCUMENT No.: SA-JER-DS011-TRJR-400100
XII. Attachment Number
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020 Page 237 of 244
ATTACHMENTS Document Name
1
SIMPLIFIED UNITS PROCESS FLOW DIAGRAMS
2
PROCESS FLOW DIAGRAMS
Reference
Revision
N/A
N/A
SA-JER-DS011-TRJR-450001
03
SA-JER-DS011-TRJR-450002
03
SA-JER-DS011-TRJR-450003
03
SA-JER-DS011-TRJR-450004
02
SA-JER-DS011-TRJR-450005
02
SA-JER-DS011-TRJR-450006
02
SA-JER-DS011-TRJR-450007
02
SA-JER-DS011-TRJR-450008
02
SA-JER-DS011-TRJR-450009
02
SA-JER-DS011-TRJR-450010
02
SA-JER-DS011-TRJR-450011
02
SA-JER-DS011-TRJR-450012
02
SA-JER-DS011-TRJR-450016
02
SA-JER-DS011-TRJR-450017
02
SA-JER-DS011-TRJR-450018
02
SA-JER-DS011-TRJR-450020
03
SA-JER-DS011-TRJR-450021
03
SA-JER-DS011-TRJR-450022
03
SA-JER-DS011-TRJR-450023
02
SA-JER-DS011-TRJR-450024
02
SA-JER-DS011-TRJR-450025
02
SA-JER-DS011-TRJR-450026
02
SA-JER-DS011-TRJR-450027
02
SA-JER-DS011-TRJR-450028
02
SA-JER-DS011-TRJR-450029
02
SA-JER-DS011-TRJR-450030
02
SA-JER-DS011-TRJR-450031
02
SA-JER-DS011-TRJR-450035
02
SA-JER-DS011-TRJR-450036
02
SA-JER-DS011-TRJR-450037
01
SA-JER-DS011-TRJR-450038
01
SA-JER-DS011-TRJR-450039
01
SA-JER-DS011-TRJR-450040
01
DOCUMENT No.: SA-JER-DS011-TRJR-400100 Attachment Number
3
REV: 01 Date: 16-MAY-2013
Document Name
TR Project No.: 02020 Page 238 of 244
Reference
Revision
SA-JER-DS011-TRJR-450041
01
SA-JER-DS011-TRJR-450043
02
SA-JER-DS011-TRJR-480001
06
SA-JER-DS011-TRJR-480002
05
SA-JER-DS011-TRJR-480003
05
SA-JER-DS011-TRJR-480004
05
SA-JER-DS011-TRJR-480005
05
SA-JER-DS011-TRJR-480006
05
SA-JER-DS011-TRJR-480007
05
SA-JER-DS011-TRJR-480008
05
SA-JER-DS011-TRJR-480009
05
SA-JER-DS011-TRJR-480010
05
SA-JER-DS011-TRJR-480011
06
SA-JER-DS011-TRJR-480012
06
SA-JER-DS011-TRJR-480013
05
SA-JER-DS011-TRJR-480015
05
SA-JER-DS011-TRJR-480016
05
SA-JER-DS011-TRJR-480017
05
SA-JER-DS011-TRJR-480018
05
SA-JER-DS011-TRJR-480019
05
SA-JER-DS011-TRJR-480020
05
SA-JER-DS011-TRJR-480021
05
SA-JER-DS011-TRJR-480022
05
SA-JER-DS011-TRJR-480023
05
SA-JER-DS011-TRJR-480024
06
SA-JER-DS011-TRJR-480025
05
SA-JER-DS011-TRJR-480026
05
SA-JER-DS011-TRJR-480027
05
SA-JER-DS011-TRJR-480028
05
SA-JER-DS011-TRJR-480029
05
SA-JER-DS011-TRJR-480030
06
SA-JER-DS011-TRJR-480031
05
SA-JER-DS011-TRJR-480032
05
SA-JER-DS011-TRJR-480033
05
SA-JER-DS011-TRJR-480034
05
SA-JER-DS011-TRJR-480035
05
SA-JER-DS011-TRJR-480036
05
SA-JER-DS011-TRJR-480037
05
SA-JER-DS011-TRJR-480038
05
P&IDS
DOCUMENT No.: SA-JER-DS011-TRJR-400100 Attachment Number
REV: 01 Date: 16-MAY-2013
Document Name
TR Project No.: 02020 Page 239 of 244
Reference
Revision
SA-JER-DS011-TRJR-480039
05
SA-JER-DS011-TRJR-480040
05
SA-JER-DS011-TRJR-480041
05
SA-JER-DS011-TRJR-480042
06
SA-JER-DS011-TRJR-480043
05
SA-JER-DS011-TRJR-480044
05
SA-JER-DS011-TRJR-480045
05
SA-JER-DS011-TRJR-480046
05
SA-JER-DS011-TRJR-480047
05
SA-JER-DS011-TRJR-480048
06
SA-JER-DS011-TRJR-480049
05
SA-JER-DS011-TRJR-480050
05
SA-JER-DS011-TRJR-480051
05
SA-JER-DS011-TRJR-480052
05
SA-JER-DS011-TRJR-480053
05
SA-JER-DS011-TRJR-480054
06
SA-JER-DS011-TRJR-480055
05
SA-JER-DS011-TRJR-480056
06
SA-JER-DS011-TRJR-480057
05
SA-JER-DS011-TRJR-480058
05
SA-JER-DS011-TRJR-480059
05
SA-JER-DS011-TRJR-480060
05
SA-JER-DS011-TRJR-480061
05
SA-JER-DS011-TRJR-480062
05
SA-JER-DS011-TRJR-480063
05
SA-JER-DS011-TRJR-480064
05
SA-JER-DS011-TRJR-480065
05
SA-JER-DS011-TRJR-480066
05
SA-JER-DS011-TRJR-480067
05
SA-JER-DS011-TRJR-480068
05
SA-JER-DS011-TRJR-480069
05
SA-JER-DS011-TRJR-480070
05
SA-JER-DS011-TRJR-480071
05
SA-JER-DS011-TRJR-480072
05
SA-JER-DS011-TRJR-480073
05
SA-JER-DS011-TRJR-480074
05
SA-JER-DS011-TRJR-480075
05
SA-JER-DS011-TRJR-480076
05
SA-JER-DS011-TRJR-480077
05
SA-JER-DS011-TRJR-480078
05
DOCUMENT No.: SA-JER-DS011-TRJR-400100 Attachment Number
REV: 01 Date: 16-MAY-2013
Document Name
TR Project No.: 02020 Page 240 of 244
Reference
Revision
SA-JER-DS011-TRJR-480079
05
SA-JER-DS011-TRJR-480080
05
SA-JER-DS011-TRJR-480081
05
SA-JER-DS011-TRJR-480082
05
SA-JER-DS011-TRJR-480083
05
SA-JER-DS011-TRJR-480084
05
SA-JER-DS011-TRJR-480085
05
SA-JER-DS011-TRJR-480086
05
SA-JER-DS011-TRJR-480087
05
SA-JER-DS011-TRJR-480088
05
SA-JER-DS011-TRJR-480089
05
SA-JER-DS011-TRJR-480090
05
SA-JER-DS011-TRJR-480091
06
SA-JER-DS011-TRJR-480092
05
SA-JER-DS011-TRJR-480093
05
SA-JER-DS011-TRJR-480094
05
SA-JER-DS011-TRJR-480095
05
SA-JER-DS011-TRJR-480096
05
SA-JER-DS011-TRJR-480097
05
SA-JER-DS011-TRJR-480098
05
SA-JER-DS011-TRJR-480099
05
SA-JER-DS011-TRJR-480100
05
SA-JER-DS011-TRJR-480101
05
SA-JER-DS011-TRJR-480102
05
SA-JER-DS011-TRJR-480103
06
SA-JER-DS011-TRJR-480104
05
SA-JER-DS011-TRJR-480105
06
SA-JER-DS011-TRJR-480106
06
SA-JER-DS011-TRJR-480107
05
SA-JER-DS011-TRJR-480108
05
SA-JER-DS011-TRJR-480109
05
SA-JER-DS011-TRJR-480110
05
SA-JER-DS011-TRJR-480111
05
SA-JER-DS011-TRJR-480112
05
SA-JER-DS011-TRJR-480113
05
SA-JER-DS011-TRJR-480114
05
SA-JER-DS011-TRJR-480115
06
SA-JER-DS011-TRJR-480116
05
SA-JER-DS011-TRJR-480117
05
SA-JER-DS011-TRJR-480118
06
DOCUMENT No.: SA-JER-DS011-TRJR-400100 Attachment Number
4
REV: 01 Date: 16-MAY-2013
Document Name
TR Project No.: 02020 Page 241 of 244
Reference
Revision
SA-JER-DS011-TRJR-480119
06
SA-JER-DS011-TRJR-480120
05
SA-JER-DS011-TRJR-480121
06
SA-JER-DS011-TRJR-480122
05
SA-JER-DS011-TRJR-480123
05
SA-JER-DS011-TRJR-480124
05
SA-JER-DS011-TRJR-480125
05
SA-JER-DS011-TRJR-480126
05
SA-JER-DS011-TRJR-480127
05
SA-JER-DS011-TRJR-480128
05
SA-JER-DS011-TRJR-480132
05
SA-JER-DS011-TRJR-480133
05
SA-JER-DS011-TRJR-480134
05
SA-JER-DS011-TRJR-480135
05
SA-JER-DS011-TRJR-480136
05
SA-JER-DS011-TRJR-480137
05
SA-JER-DS011-TRJR-480138
05
SA-JER-DS011-TRJR-480139
05
SA-JER-DS011-TRJR-480140
05
SA-JER-DS011-TRJR-480141
05
SA-JER-DS011-TRJR-480142
06
SA-JER-DS011-TRJR-480144
05
SA-JER-DS011-TRJR-480201
05
SA-JER-DS011-TRJR-480202
05
SA-JER-DS011-TRJR-480203
05
SA-JER-DS011-TRJR-480204
05
SA-JER-DS011-TRJR-480205
05
SA-JER-DS011-TRJR-480206
05
SA-JER-DS011-TRJR-480207
05
SA-JER-DS011-TRJR-480209
05
SA-JER-DS011-TRJR-480211
05
SA-JER-DS011-TRJR-480212
05
SA-JER-DS011-TRJR-480213
05
SA-JER-DS011-TRJR-480214
05
SA-JER-DS011-TRJR-480215
05
SA-JER-DS011-TRJR-480216
03
SA-JER-DS011-TRJR-480218
05
SA-JER-DS011-TRJR-480219
05
SA-JER-DS011-TRJR-480220
05
PLANIMETRIC P&ID FOR UTILITIES
DOCUMENT No.: SA-JER-DS011-TRJR-400100 Attachment Number
REV: 01 Date: 16-MAY-2013
Document Name
TR Project No.: 02020 Page 242 of 244
Reference
Revision
SA-JER-DS011-TRJR-480221
05
SA-JER-DS011-TRJR-480222
05
SA-JER-DS011-TRJR-480223
05
SA-JER-DS011-TRJR-480224
05
SA-JER-DS011-TRJR-480225
05
SA-JER-DS011-TRJR-480226
05
SA-JER-DS011-TRJR-480227
05
SA-JER-DS011-TRJR-480228
05
SA-JER-DS011-TRJR-480229
05
SA-JER-DS011-TRJR-480230
05
SA-JER-DS011-TRJR-480231
05
SA-JER-DS011-TRJR-480232
05
SA-JER-DS011-TRJR-480233
05
SA-JER-DS011-TRJR-480237
05
SA-JER-DS011-TRJR-480238
05
SA-JER-DS011-TRJR-480239
05
SA-JER-DS011-TRJR-480240
05
SA-JER-DS011-TRJR-480242
05
SA-JER-DS011-TRJR-480243
05
SA-JER-DS011-TRJR-480244
03
SA-JER-DS011-TRJR-480245
03
SA-JER-DS011-TRJR-480246
03
SA-JER-DS011-TRJR-480247
03
SA-JER-DS011-TRJR-480248
03
SA-JER-DS011-TRJR-480249
03
SA-JER-DS011-TRJR-480250
03
SA-JER-DS011-TRJR-480251
03
SA-JER-DS011-TRJR-480252
03
SA-JER-DS011-TRJR-480253
03
SA-JER-DS011-TRJR-480254
03
SA-JER-DS011-TRJR-480255
03
SA-JER-DS011-TRJR-480256
03
SA-JER-DS011-TRJR-480257
03
SA-JER-DS011-TRJR-480258
03
SA-JER-DS011-TRJR-480259
03
SA-JER-DS011-TRJR-480260
03
SA-JER-DS011-TRJR-480261
03
SA-JER-DS011-TRJR-480262
03
SA-JER-DS011-TRJR-480263
03
SA-JER-DS011-TRJR-480264
03
DOCUMENT No.: SA-JER-DS011-TRJR-400100 Attachment Number
REV: 01 Date: 16-MAY-2013
Document Name
TR Project No.: 02020 Page 243 of 244
Reference
Revision
SA-JER-DS011-TRJR-480265
03
SA-JER-DS011-TRJR-480266
03
SA-JER-DS011-TRJR-480267
03
SA-JER-DS011-TRJR-480268
03
SA-JER-DS011-TRJR-480269
03
SA-JER-DS011-TRJR-480270
03
SA-JER-DS011-TRJR-480271
03
SA-JER-DS011-TRJR-480272
03
SA-JER-DS011-TRJR-480273
04
SA-JER-DS011-TRJR-480274
04
SA-JER-DS011-TRJR-480275
04
SA-JER-DS011-TRJR-480289
05
SA-JER-DS011-TRJR-480290
05
SA-JER-DS011-TRJR-480291
05
SA-JER-DS011-TRJR-480306
05
SA-JER-DS011-TRJR-480307
05
SA-JER-DS011-TRJR-480308
05
SA-JER-DS011-TRJR-480309
05
SA-JER-DS011-TRJR-480310
05
SA-JER-DS011-TRJR-480311
05
SA-JER-DS011-TRJR-480312
05
SA-JER-DS011-TRJR-480313
05
SA-JER-DS011-TRJR-480314
00
SA-JER-DS011-TRJR-480315 SA-JER-DS011-TRJR-290001
00 03
5
PROCESS MATERIAL BALANCE
6
LIGHT ARABIAN CASE PFDS AND H&M BALANCE
7
UTILITIES MATERIAL BALANCE
SA-JER-DS011-TRJR-670001
8
LINE LIST
SA-JER-DS011-TRJR-380001
NA
NA 02
9
PROCESS BATTERY LIMIT CONDITIONS
SA-JER-DS011-TRJR-670006
02
10
UTILITIES BATTERY LIMIT CONDITIONS
SA-JER-DS011-TRJR-670007
02
11
FEED QUALITIES & EXPECTED PRODUCT PROPERTIES
12
EQUIPMENT SUMMARY
SA-JER-DS011-TRJR-381201
05
13
ELECTRICAL LOAD SUMMARY
SA-JER-DSAAA-TRJR-386101
04
14
CAUSE & EFFECT DIAGRAMS
SA-JER-DS011-TRJR-355003
06
15
F&G CAUSE & EFFECT DIAGRAMS
SA-JER-DS011-TRJR-355802
02
16
ELECTRICAL ON-LINE DIAGRAM
SA-JER-DSAAA-TRJR-626002
05
17
PLOT PLANS
18
MATERIAL SAFETY DATA SHEET (MSDS)
19 20
NA
NA
SA-JER-DS011-TRJR-272011
08
NA
NA
LIST OF HAZARDOUS SUBSTANCES
SA-JER-DS011-TRJR-670008
04
FIRE HAZARD ENVELOPE LAYOUT
SA-JER-DS011-TRJR-345801
03
DOCUMENT No.: SA-JER-DS011-TRJR-400100 Attachment Number
REV: 01 Date: 16-MAY-2013
Document Name
TR Project No.: 02020 Page 244 of 244
Reference
Revision
21
FIRE & GAS DETECTION LAYOUT
SA-JER-DS011-TRJR-345803
04
22
FIRE PROTECTION LAYOUT
SA-JER-DS011-TRJR-345802
05
23
FIRE WATER DEMAND CCTV EQUIPMENT LAYOUT, CABLE ROUTING & GROUNDING POINTS
SA-JER-DS011-TRJR-675801
01
SA-JER-DS011-TRJR-345610
02
UNIT 011 CCTV EQUIPMENT LAYOUT & CABLE ROUTING
SA-JER-DS091-TRJR-345613
02
SA-JER-DS011-TRJR-345604
05
24 25
27
PIB 05.SS106 AND US05 SCS OUTLETS LAYOUT AND CABLE ROUTING OUTDOOR LS, FB & P/LS CABLE ROUTING & GROUNDING POINTS
SA-JER-DS011-TRJR-345611
02
28
PIB 05 INDOOR LS & P/LS LAYOUT AND CABLE ROUITNG
SA-JER-DS091-TRJR-345607
03
29
FLARE LOAD SUMMARY
SA-JER-DS011-TRJR-670005
03
30
CHEMICAL SUMMARY
SA-JER-DS011-TRJR-670003
04
31
CDU/VDU PREPARATION FOR START UP
SA-JER-DS011-TRJR-400001
01
32
CDU/VDU START UP
SA-JER-DS011-TRJR-400002
01
33
CDU/VDU SHUT DOWN
SA-JER-DS011-TRJR-400003
01
34
CDU/VDU GAS OUT
SA-JER-DS011-TRJR-409227
01
35
AMINE SECTION GASSING/ START-UP/ SHUTDOWN/ DEGASSING
SA-JER-DS011-TRJR-400005
01
36
STEAM GENERATION START-UP/SHUTDOWN
SA-JER-DS011-TRJR-400006
01
37
TEMPERED WATER SYSTEM GASSING/ START-UP/ SHUTDOWN/ DEGASSING
SA-JER-DS011-TRJR-400007
01
38
CLOSE DRAIN GASSING/ START UP/ SHUTDOWN/ DEGASSING
SA-JER-DS011-TRJR-409228
01
39
E-0016/17/18 GASSING/ START-UP/ SHUTDOWN/ DEGASSING
SA-JER-DS011-TRJR-400009
01
40
VDU BYPASS
SA-JER-DS011-TRJR-400010
01
41
GENERAL EMERGENCY SHUTDOWN
SA-JER-DS011-TRJR-400011
01
42
LOSS OF INSTRUMENT AIR
SA-JER-DS011-TRJR-400012
01
43
LOSS OF PILOT GAS
SA-JER-DS011-TRJR-400013
01
44
LOSS OF POWER ELECTRIC SYSTEM
SA-JER-DS011-TRJR-400014
01
45
LOSS OF COOLING WATER
SA-JER-DS011-TRJR-400015
01
46
SHUTDOWN WITH LARGE RECIRCULATION
SA-JER-DS011-TRJR-400016
01
47
LOSS OF LGO PA
SA-JER-DS011-TRJR-400017
01
48
LOSS OF HGO PA
SA-JER-DS011-TRJR-400018
01
49
LOSS OF TEMPERED WATER
SA-JER-DS011-TRJR-400019
01
50
LOSS OF BFW
SA-JER-DS011-TRJR-400020
01
51
LOSS OF HVGO
SA-JER-DS011-TRJR-400021
01
52
LOSS OF DESALTER WATER
SA-JER-DS011-TRJR-400022
01
53
EXTERNAL FIRE
SA-JER-DS011-TRJR-400023
01
54
LOSS OF FLOW WASH OIL BED 1
SA-JER-DS011-TRJR-400024
01
55
LOSS OF LVGO PA
SA-JER-DS011-TRJR-400025
01
56
LOSS OF MVGO/HVGO PA
SA-JER-DS011-TRJR-400026
01
57
LOSS OF QUENCH BOTTOM OF C-0003
SA-JER-DS011-TRJR-400027
01
58
LOSS OF PUMP G-0018 VACUUM RESIDUE
SA-JER-DS011-TRJR-400028
01
26
DOCUMENT No.: SA-JER-DS011-TRJR-400100 Attachment Number 59 60
REV: 01 Date: 16-MAY-2013
Document Name
TR Project No.: 02020 Page 245 of 244
Reference
Revision
LOSS OF K-0001 COMPRESSOR OFF-GAS
SA-JER-DS011-TRJR-400029
01 03
DESALTER 011 D 0001 GASSING START UP
SA-JER-DS011-TRJR-409201
61
HEATER 011-F-0001 SHUTDOWN/START-UP
SA-JER-DS011-TRJR-409202
02
62
HEATER 011-F-0002 SHUTDOWN/START-UP
SA-JER-DS011-TRJR-409203
02
63
HEATER 011-F-0002 DECOKING
SA-JER-DS011-TRJR-409204
02
64
COMPRESSOR 011-K-0001 SHUTDOWN/DEGASSING/GASSING/START-UP
SA-JER-DS011-TRJR-409205
02
65
UTILITIES SHUTDOWN START UP
SA-JER-DS011-TRJR-409206
03
66
COMBUSTIBLE FUEL GAS SHUTDOWN DEGASSING GASSING START UP
SA-JER-DS011-TRJR-409207
03
67
FLARE SYSTEM SHUTDOWN DEGASSING GASSING START UP
SA-JER-DS011-TRJR-409208
03 02
68
011-E-0040 SHUTDOWN/DEGASSING/GASSING/START-UP
SA-JER-DS011-TRJR-409209
69
FLUSH OIL SYSTEM
SA-JER-DS011-TRJR-409210
03
70
PUMP HANDLING
SA-JER-DS011-TRJR-409211
02
71
FILTER S 0001 SHUTDOWN DEGASSING GASSING START UP
SA-JER-DS011-TRJR-409212
03
72
FILTER S 0002 SHUTDOWN DEGASSING GASSING START UP
SA-JER-DS011-TRJR-409213
03
73
HIGH HIGH PRESSURE IN DESALTER RELIEVES VALVE OPEN TO FLARE
SA-JER-DS011-TRJR-409214
02
74
LOSS OF REFLUX OVERHEAD SYSTEM 011-C-0001
SA-JER-DS011-TRJR-409215
02
75
HIGH HIGH PRESSURE IN 011-C-0001
SA-JER-DS011-TRJR-409216
02
76
HEATER TUBE FAILURE IN 011-F-0001/011-F-0002
SA-JER-DS011-TRJR-409217
02
HIGH HIGH PRESSURE IN 011-C-0002
SA-JER-DS011-TRJR-409218
02 02
77 78
LOSS OF REFLUX OVERHEAD SYSTEM 011-C-0002
SA-JER-DS011-TRJR-409219
79
LOSS OF PUMP 011-G-0014 ATMOSPHERIC RESIDUE
SA-JER-DS011-TRJR-409220
02
80
LOSS OF STEAM MPS/LPS
SA-JER-DS011-TRJR-409221
02
81
LOSS OF NITROGEN
SA-JER-DS011-TRJR-409222
02
82
LOSS OF NEUTRALIZING AGENT DEMULSIFIER CORROSION INHIBITOR PHOSPHATE
SA-JER-DS011-TRJR-409223
02
83
LOSS OF VACUUM IN 011-C-0003
SA-JER-DS011-TRJR-409224
02 02
84
LOSS OF SOUR WATER
SA-JER-DS011-TRJR-409225
85
DESALTER 011 D 0001 SHUTDOWN DEGASSING
SA-JER-DS011-TRJR-409226
03
86
COMBUSTIBLE PILOT GAS SHUTDOWN DEGASSING GASSING START-UP
SA-JER-DS011-TRJR-409229
01
87
SPECIFICATION FOR PRESSURE SAFETY VALVE INTERLOCKS
N/A
02
BLIND LIST
N/A
N/A
88
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 00 Date: 22-FEB-2012
TR Project No.: 02020
ATTACHMENT 1.
SIMPLIFIED UNITS PROCESS FLOW DIAGRAMS
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 2.
PROCESS FLOW DIAGRAMS Document Number SA-JER-DS011-TRJR-450001 SA-JER-DS011-TRJR-450002 SA-JER-DS011-TRJR-450003 SA-JER-DS011-TRJR-450004 SA-JER-DS011-TRJR-450005 SA-JER-DS011-TRJR-450006 SA-JER-DS011-TRJR-450007 SA-JER-DS011-TRJR-450008 SA-JER-DS011-TRJR-450009 SA-JER-DS011-TRJR-450010 SA-JER-DS011-TRJR-450011 SA-JER-DS011-TRJR-450012 SA-JER-DS011-TRJR-450016 SA-JER-DS011-TRJR-450017 SA-JER-DS011-TRJR-450018 SA-JER-DS011-TRJR-450020 SA-JER-DS011-TRJR-450021 SA-JER-DS011-TRJR-450022 SA-JER-DS011-TRJR-450023 SA-JER-DS011-TRJR-450024 SA-JER-DS011-TRJR-450025 SA-JER-DS011-TRJR-450026 SA-JER-DS011-TRJR-450027 SA-JER-DS011-TRJR-450028 SA-JER-DS011-TRJR-450029 SA-JER-DS011-TRJR-450030 SA-JER-DS011-TRJR-450031
Description
Rev.
PFD FOR CDU AND VDU CRUDE PREHEAT-PREFLASH, SH 1 OF 2 PFD FOR CDU AND VDU CRUDE DISTILLATION PFD FOR CDU AND VDU VACUUM DISTILLATION, SH 1 OF 2 PFD FOR CDU AND VDU - MAXI NAPHTHA CASE CRUDE PREHEAT-PREFLASH PFD FOR CDU AND VDU - MAXI NAPHTHA CASE CRUDE DISTILLATION PFD FOR CDU AND VDU - MAXI NAPHTHA CASE VACUUM DISTILLATION PFD FOR CDU AND VDU - MAXI KEROSENE CASE CRUDE PREHEAT-PREFLASH PFD FOR CDU AND VDU - MAXI KEROSENE CASE CRUDE DISTILLATION PFD FOR CDU AND VDU - MAXI KEROSENE CASE VACUUM DISTILLATION PFD FOR CDU AND VDU - MAXI KEROSENE IN DIESEL POOL CASE CRUDE PREHEAT-PREFLASH PFD FOR CDU AND VDU - MAXI KEROSENE IN DIESEL POOL CASE CRUDE DISTILLATION PFD FOR CDU AND VDU - MAXI KEROSENE IN DIESEL POOL CASE VACUUM PFD FOR CDU AND VDU NAPHTHA SPLITTER REB. DUTY = 15Gcal-h CASE CRUDE PREHEAT-PREFLASH PFD FOR CDU AND VDU NAPHTHA SPLITTER REB. DUTY = 15Gcal-h CASE CRUDE DISTILLATION PFD FOR CDU AND VDU NAPHTHA SPLITTER REB. DUTY = 15Gcal-h CASE VACUUM DISTILLATION PFD FOR CDU AND VDU CRUDE PREHEAT-PREFLASH, SH 2 OF 2 PFD FOR CDU AND VDU VACUUM DISTILLATION, SH 2 OF 2 PFD FOR CDU AND VDU PROCESS STREAM SUMMARY SH 1 OF 2 PFD FOR CDU AND VDU - MAXI NAPHTHA CASE - CRUDE PREHEAT/PREFLASH PFD FOR CDU AND VDU - MAXI NAPHTHA CASE - VACUUM DISTILLATION PFD FOR CDU AND VDU - MAXI NAPHTHA CASE - PROCESS STREAM SUMMARY SH 1 OF 2 PFD FOR CDU AND VDU - MAXI KEROSENE CASE - CRUDE PREHEAT/PREFLASH PFD FOR CDU AND VDU - MAXI KEROSENE CASE - VACUUM DISTILLATION PFD FOR CDU AND VDU - MAXI KEROSENE CASE - PROCESS STREAM SUMMARY SH 1 OF 2 PFD FOR CDU AND VDU - KEROSENE IN DIESEL POOL CASE CRUDE PREHEAT/PREFLASH PFD FOR CDU AND VDU - KEROSENE IN DIESEL POOL CASE VACUUM DISTILLATION PFD FOR CDU AND VDU - KEROSENE IN DIESEL POOL CASE -
03 03 03 02 02 02 02 02 02 02 02 02 02 02 02 03 03 03 02 02 02 02 02 02 02 02 02
DOCUMENT No.: SA-JER-DS011-TRJR-400100
Document Number SA-JER-DS011-TRJR-450035 SA-JER-DS011-TRJR-450036 SA-JER-DS011-TRJR-450037 SA-JER-DS011-TRJR-450038 SA-JER-DS011-TRJR-450039 SA-JER-DS011-TRJR-450040 SA-JER-DS011-TRJR-450041 SA-JER-DS011-TRJR-450043
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
Description PROCESS STREAM SUMMARY SH 1 OF 2 PFD FOR CDU AND VDU NAPHTHA SPLITTER REB. DUTY = 15Gcal-h CASE - CRUDE PREHEAT/PREFLASH PFD FOR CDU AND VDU NAPHTHA SPLITTER REB. DUTY = 15Gcal-h CASE - VACUUM DISTILLATION PFD FOR CDU AND VDU NAPHTHA SPLITTER REB. DUTY = 15Gcal-h CASE - PROCESS STREAM SUMMARY SH 1 OF 2 PFD FOR CDU AND VDU PROCESS STREAM SUMMARY SH 2 OF 2 PFD FOR CDU AND VDU - MAXI NAPHTHA CASE - PROCESS STREAM SUMMARY SH 2 OF 2 PFD FOR CDU AND VDU - MAXI KEROSENE CASE - PROCESS STREAM SUMMARY SH 2 OF 2 PFD FOR CDU AND VDU - KEROSENE IN DIESEL POOL CASE PROCESS STREAM SUMMARY SH 2 OF 2 PFD FOR CDU AND VDU NAPHTHA SPLITTER REB. DUTY = 15Gcal-h CASE - PROCESS STREAM SUMMARY SH 2 OF 2
Rev. 02 02 01 01 01 01 01 02
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 3.
P&IDS Document Number
Description
Rev.
SA-JER-DS011-TRJR-480001 SA-JER-DS011-TRJR-480002 SA-JER-DS011-TRJR-480003
PID FOR CDU CRUDE FEED INLET PID FOR CDU CRUDE CHARGE PUMPS PID FOR CDU FRESH CRUDE EXCHANGERS
06 05 05
SA-JER-DS011-TRJR-480004
PID FOR CDU CRUDE PREHEAT - CDU OVERHEAD
05
SA-JER-DS011-TRJR-480005 SA-JER-DS011-TRJR-480006 SA-JER-DS011-TRJR-480007 SA-JER-DS011-TRJR-480008 SA-JER-DS011-TRJR-480009 SA-JER-DS011-TRJR-480010 SA-JER-DS011-TRJR-480011 SA-JER-DS011-TRJR-480012 SA-JER-DS011-TRJR-480013 SA-JER-DS011-TRJR-480015 SA-JER-DS011-TRJR-480016 SA-JER-DS011-TRJR-480017 SA-JER-DS011-TRJR-480018 SA-JER-DS011-TRJR-480019 SA-JER-DS011-TRJR-480020 SA-JER-DS011-TRJR-480021 SA-JER-DS011-TRJR-480022 SA-JER-DS011-TRJR-480023 SA-JER-DS011-TRJR-480024 SA-JER-DS011-TRJR-480025 SA-JER-DS011-TRJR-480026 SA-JER-DS011-TRJR-480027 SA-JER-DS011-TRJR-480028 SA-JER-DS011-TRJR-480029 SA-JER-DS011-TRJR-480030 SA-JER-DS011-TRJR-480031 SA-JER-DS011-TRJR-480032 SA-JER-DS011-TRJR-480033 SA-JER-DS011-TRJR-480034 SA-JER-DS011-TRJR-480035
PID FOR CDU FRESH CRUDE - PREFLASH OVERHEAD EXCHANGERS PID FOR CDU CRUDE PREHEAT - PREFLASH TOP AND LVGO PA PID FOR CDU CRUDE PREHEAT - LAGO PID FOR CDU CRUDE PREHEAT - KERO PA PID FOR CDU CRUDE PREHEAT - KERO PID FOR CDU CRUDE PREHEAT - HAGO PID FOR CDU DESALTER FIRST STAGE PID FOR CDU DESALTER SECOND STAGE PID FOR CDU DESALTER RECIRCULATION PUMPS PID FOR CDU DESALTED CRUDE PUMPS PID FOR CDU DESALTED CRUDE-HVGO EXCHANGERS PID FOR CDU CRUDE PREHEAT - LAGO AND HAGO PID FOR CDU CRUDE PREHEAT - LAGO PA PID FOR CDU CRUDE PREHEAT - VAC RESID. PID FOR CDU PREFLASH COLUMN PID FOR CDU PREFLASH BOTTOM PUMPS PID FOR CDU PREFLASH REFLUX DRUM PID FOR CDU PREFLASH REFLUX DRUM PID FOR CDU TOPPED CRUDE PREHEAT - HVGO PID FOR CDU TOPPED CRUDE PREHEAT - HVGO PA PID FOR CDU TOPPED CRUDE PREHEAT - HAGO PA PID FOR CDU TOPPED CRUDE PREHEAT - VACUUM RESIDUE PID FOR CDU TOPPED CRUDE PREHEAT - HVGO PA PID FOR CDU TOPPED CRUDE PREHEAT - VAC. RESIDUE PID FOR CDU CRUDE HEATER INLET SH 1 OF 4 PID FOR CDU CRUDE HEATER INLET SH 2 OF 4 PID FOR CDU CRUDE HEATER INLET SH 3 OF 4 PID FOR CDU CRUDE HEATER INLET SH 4 OF 4 PID FOR CDU CRUDE HEATER PASS 1 - PROCESS COIL PID FOR CDU CRUDE HEATER PASS 2 - PROCESS COIL
05 05 05 05 05 05 06 06 05 05 05 05 05 05 05 05 05 05 06 05 05 05 05 05 06 05 05 05 05 05
DOCUMENT No.: SA-JER-DS011-TRJR-400100
Document Number SA-JER-DS011-TRJR-480036 SA-JER-DS011-TRJR-480037 SA-JER-DS011-TRJR-480038 SA-JER-DS011-TRJR-480039 SA-JER-DS011-TRJR-480040 SA-JER-DS011-TRJR-480041 SA-JER-DS011-TRJR-480042 SA-JER-DS011-TRJR-480043 SA-JER-DS011-TRJR-480044 SA-JER-DS011-TRJR-480045 SA-JER-DS011-TRJR-480046 SA-JER-DS011-TRJR-480047 SA-JER-DS011-TRJR-480048 SA-JER-DS011-TRJR-480049 SA-JER-DS011-TRJR-480050 SA-JER-DS011-TRJR-480051 SA-JER-DS011-TRJR-480052 SA-JER-DS011-TRJR-480053 SA-JER-DS011-TRJR-480054 SA-JER-DS011-TRJR-480055 SA-JER-DS011-TRJR-480056 SA-JER-DS011-TRJR-480057 SA-JER-DS011-TRJR-480058 SA-JER-DS011-TRJR-480059 SA-JER-DS011-TRJR-480060 SA-JER-DS011-TRJR-480061 SA-JER-DS011-TRJR-480062 SA-JER-DS011-TRJR-480063 SA-JER-DS011-TRJR-480064 SA-JER-DS011-TRJR-480065 SA-JER-DS011-TRJR-480066 SA-JER-DS011-TRJR-480067 SA-JER-DS011-TRJR-480068 SA-JER-DS011-TRJR-480069 SA-JER-DS011-TRJR-480070 SA-JER-DS011-TRJR-480071 SA-JER-DS011-TRJR-480072 SA-JER-DS011-TRJR-480073 SA-JER-DS011-TRJR-480074 SA-JER-DS011-TRJR-480075 SA-JER-DS011-TRJR-480076 SA-JER-DS011-TRJR-480077 SA-JER-DS011-TRJR-480078 SA-JER-DS011-TRJR-480079 SA-JER-DS011-TRJR-480080 SA-JER-DS011-TRJR-480081 SA-JER-DS011-TRJR-480082
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
Description PID FOR CDU CRUDE HEATER PASS 3 - PROCESS COIL PID FOR CDU CRUDE HEATER PASS 4 - PROCESS COIL PID FOR CDU CRUDE HEATER PASS 5 - PROCESS COIL PID FOR CDU CRUDE HEATER PASS 6 - PROCESS COIL PID FOR CDU CRUDE HEATER PASS 7 - PROCESS COIL PID FOR CDU CRUDE HEATER PASS 8 - PROCESS COIL PID FOR CDU CRUDE HEATER-STEAM COIL PID FOR CDU CRUDE DISTILLATION COLUMN SH 1 OF 2 PID FOR CDU CRUDE DISTILLATION COLUMN SH 2 OF 2 PID FOR CDU OVERHEAD CONDENSER PID FOR CDU CDU REFLUX DRUM PID FOR CDU CDU REFLUX PUMPS PID FOR CDU NAPHTHA CONDENSER PID FOR CDU NAPHTHA TRIM COOLER PID FOR CDU TOTAL NAPHTHA DRUM PID FOR CDU NAPHTHA TO NHDT PUMPS PID FOR CDU KEROSENE STRIPPER PID FOR CDU KEROSENE PUMPS PID FOR CDU LIGHT ATMOSPHERIC GASOIL STRIPPER PID FOR CDU LAGO PUMPS PID FOR CDU HEAVY ATMOSPHERIC GASOIL STRIPPER PID FOR CDU HEAVY ATMOSPHERIC GASOIL PUMPS PID FOR CDU KERO PRODUCTS COOLERS PID FOR CDU KERO-LAGO-HAGO PRODUCTS COOLERS PID FOR CDU LAGO PRODUCTS COOLERS PID FOR CDU HAGO PRODUCTS COOLERS PID FOR CDU HAGO PRODUCTS COOLERS PID FOR CDU KEROSENE PA PUMPS PID FOR CDU LAGO PA PUMPS PID FOR CDU HAGO PA PUMPS PID FOR CDU ATM RESIDUE PUMPS PID FOR CDU VACUUM HEATER INLET SH 1 OF 5 PID FOR CDU VACUUM HEATER INLET SH 2 OF 5 PID FOR CDU VACUUM HEATER INLET SH 3 OF 5 PID FOR CDU VACUUM HEATER INLET SH 4 OF 5 PID FOR CDU VACUUM HEATER PASS 1-PROCESS COIL PID FOR CDU VACUUM HEATER PASS 2-PROCESS COIL PID FOR CDU VACUUM HEATER PASS 3-PROCESS COIL PID FOR CDU VACUUM HEATER PASS 4-PROCESS COIL PID FOR CDU VACUUM HEATER PASS 5-PROCESS COIL PID FOR CDU VACUUM HEATER PASS 6-PROCESS COIL PID FOR CDU VACUUM HEATER PASS 7-PROCESS COIL PID FOR CDU VACUUM HEATER PASS 8-PROCESS COIL PID FOR CDU VACUUM HEATER PID FOR CDU VACUUM COLUMN SH 1 OF 2 PID FOR CDU VACUUM COLUMN BOTTOM, SH 2 OF 2 PID FOR CDU PRE-CONDENSER SH 1 OF 2
Rev. 05 05 05 05 05 05 06 05 05 05 05 05 06 05 05 05 05 05 06 05 06 05 05 05 05 05 05 05 05 05 05 05 05 05 05 05 05 05 05 05 05 05 05 05 05 05 05
DOCUMENT No.: SA-JER-DS011-TRJR-400100
Document Number SA-JER-DS011-TRJR-480083 SA-JER-DS011-TRJR-480084 SA-JER-DS011-TRJR-480085 SA-JER-DS011-TRJR-480086 SA-JER-DS011-TRJR-480087 SA-JER-DS011-TRJR-480088 SA-JER-DS011-TRJR-480089 SA-JER-DS011-TRJR-480090 SA-JER-DS011-TRJR-480091 SA-JER-DS011-TRJR-480092 SA-JER-DS011-TRJR-480093 SA-JER-DS011-TRJR-480094 SA-JER-DS011-TRJR-480095 SA-JER-DS011-TRJR-480096 SA-JER-DS011-TRJR-480097 SA-JER-DS011-TRJR-480098 SA-JER-DS011-TRJR-480099 SA-JER-DS011-TRJR-480100 SA-JER-DS011-TRJR-480101 SA-JER-DS011-TRJR-480102 SA-JER-DS011-TRJR-480103 SA-JER-DS011-TRJR-480104 SA-JER-DS011-TRJR-480105 SA-JER-DS011-TRJR-480106 SA-JER-DS011-TRJR-480107 SA-JER-DS011-TRJR-480108 SA-JER-DS011-TRJR-480109 SA-JER-DS011-TRJR-480110 SA-JER-DS011-TRJR-480111 SA-JER-DS011-TRJR-480112 SA-JER-DS011-TRJR-480113 SA-JER-DS011-TRJR-480114 SA-JER-DS011-TRJR-480115 SA-JER-DS011-TRJR-480116 SA-JER-DS011-TRJR-480117 SA-JER-DS011-TRJR-480118 SA-JER-DS011-TRJR-480119 SA-JER-DS011-TRJR-480120 SA-JER-DS011-TRJR-480121 SA-JER-DS011-TRJR-480122 SA-JER-DS011-TRJR-480123 SA-JER-DS011-TRJR-480124 SA-JER-DS011-TRJR-480125 SA-JER-DS011-TRJR-480126 SA-JER-DS011-TRJR-480127 SA-JER-DS011-TRJR-480128 SA-JER-DS011-TRJR-480132
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
Description PID FOR CDU PRE-CONDENSER SH 2 OF 2 PID FOR CDU VACUUM SYSTEM EJECTORS PID FOR CDU VACUUM SYSTEM CONDENSERS PID FOR CDU VACUUM SYSTEM RECOVERY DRUM PID FOR CDU RECOVERED OIL PUMPS PID FOR CDU VACUUM SYSTEM SOUR WATER PUMPS PID FOR CDU VDU OFF GAS SEAL POT PID FOR CDU OFF GAS COMPRESSOR KO DRUM PID FOR CDU VDU OFF GAS COMPRESSOR PID FOR CDU VDU OFF GAS COOLER PID FOR CDU VDU OFF GAS AMINE ABSORBER PID FOR CDU VDU OFF GAS AMINE ABSORBER PID FOR CDU RICH AMINE PUMPS PID FOR CDU LVGO PUMPS PID FOR CDU LVGO PA- COOLER PID FOR CDU LVGO COOLER, SH 3 OF 3 PID FOR CDU MVGO PUMPS PID FOR CDU VGO COOLER PID FOR CDU HVGO PUMPS PID FOR CDU HVGO INTERNAL REFLUX FILTERS PID FOR CDU VACUUM RESIDUE PUMPS PID FOR CDU VACUUM RESID STEAM GENERATOR PID FOR CDU STEAM DRUM PID FOR CDU STRIPPING STEAM INJECTION PID FOR CDU BRINE-DESALTING WATER EXCHANGERS PID FOR CDU BRINE COOLER PID FOR CDU BRINE TRIM COOLER PID FOR CDU DESALTING WATER SURGE DRUM PID FOR CDU DESALTING WATER PUMPS PID FOR CDU DESALTING WATER SURGE DRUM PID FOR CDU SOUR WATER RECOVERY DRUM PID FOR CDU CDU SOUR WATER PUMPS PID FOR CDU CRUDE HEATER BURNER CONTROL WEST PID FOR CDU CRUDE HEATER BURNER CONTROL EAST PID FOR CDU CRUDE HEATER STACK AND DETAILS PID FOR CDU VACUUM HEATER BURNER CONTROL WEST PID FOR CDU VACUUM HEATER BURNER CONTROL EAST PID FOR CDU VACUUM HEATER STACK AND DETAILS PID FOR CDU COMBUSTION AIR PREHEATING PID FOR CDU TEMPERED WATER DRUM PID FOR CDU TEMPERED WATER COOLER PID FOR CDU TEMPERED WATER PUMPS PID FOR CDU DEMULSIFIER INJECTION PACKAGE PID FOR CDU NEUTRALIZING AGENT INJECTION PACKAGE PID FOR CDU CORROSION INHIBITOR INJECTION PACKAGE PID FOR CDU PHOSPHATE INJECTION PACKAGE PID FOR CDU B.L. PROCESS No 1
Rev. 05 05 05 05 05 05 05 05 06 05 05 05 05 05 05 05 05 05 05 05 06 05 06 06 05 05 05 05 05 05 05 05 06 05 05 06 06 05 06 05 05 05 05 05 05 05 05
DOCUMENT No.: SA-JER-DS011-TRJR-400100
Document Number SA-JER-DS011-TRJR-480133 SA-JER-DS011-TRJR-480134 SA-JER-DS011-TRJR-480135 SA-JER-DS011-TRJR-480136 SA-JER-DS011-TRJR-480137 SA-JER-DS011-TRJR-480138 SA-JER-DS011-TRJR-480139 SA-JER-DS011-TRJR-480140 SA-JER-DS011-TRJR-480141 SA-JER-DS011-TRJR-480142 SA-JER-DS011-TRJR-480144
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
Description PID FOR CDU B.L. PROCESS No 2 PID FOR CDU B.L. PROCESS No 3 PID FOR CDU B.L. PROCESS No 4 PID FOR CDU B.L. PROCESS No 5 PID FOR CDU B.L. PROCESS No 7 PID FOR CDU B.L. PROCESS No 8 PID FOR CDU VACUUM HEATER INLET, SH 5 OF 5 PID FOR CDU B.L. PROCESS No 6 PID FOR CDU HVGO PA FILTER PID FOR CDU PREFLASH STRIPPING STEAM, SH 3 OF 3 PID FOR CDU TWIN UNIT-IPS B.L. DETAILS
Rev. 05 05 05 05 05 05 05 05 05 06 05
41
41
DETAIL "A"
40
40
1"
37
60º
FLOW
HISR 0030 +
NOTE 3 FB LO
36
0.2%
NOTE 6
4792
INJECTION QUILL
NOTE 2
33
1" ø=33.4mm ext.
31 30
ZC 0303
ZC 0304
ZC 0305
ZC 0306
ZC 0307
ZC 0308
ZC 0309
ZC 0310
ZC 0311
ZC 0312
ZC 0313
ZC 0314
ZC 0316
ZC 0317
ZC 0318
ZC 0319
ZC 0320
ZC 0321
ZC 0322
ZC 0323
ZC 0330
ZC 0331
ZC 0332
ZC 0334
ZC 0335
ZC 0336
ZC 0337
ZC 0340
ZC 0341
ZC 0342
ZC 0343
ZC 0344
ZC 0345
ZC 0346
ZC 0347
ZC 0348
ZC 0349
ZC 0350
ZC 0351
ZC 0352
ZC 0353
ZC 0354
ZC 0355
ZC 0356
ZC 0357
ZC 0358
ZC 0359
ZC 0360
ZC 0361
ZC 0368
ZC 0370
ZC 0371
ZC 0372
ZC 0373
ZC 0374
ZC 0375
ZC 0376
ZC 0377
ZC 0363
38 37 36 35 34 33
+
3/4"
PZV 0078 B
V
ZC 0378
ZC 0379
ZC 0380
ZC 0387
ZC 0390
ZC 0394
ZC 0395
ZC 0396
ZC 0397
ZC 0398
ZC 0399
ZC 0400
ZC 0401
ZC 0402
ZC 0403
ZC 0406
ZC 0407
ZC 0408
ZC 0409
ZC 0410
ZC 0411
ZC 0412
ZC 0413
ZC 0414
ZC 0415
ZC 0416
ZC 0417
ZC 0418
32
+
8"x4" FB LO NOTE 3
3/4"
NOTE 6 8"x3"
60º
31 30 29
10"-CRU-011001002-103CS1P-N
3/4"
VIEW FROM X
28
ZC 0302
8"x3"
3"L4" 14.92
101CH2F 103CS1P
29
011-SP-0019
NOTE 4 3/4"-LFL-011001301-101CH2F-N
34
32
HIXS 0030 A
+
8"x4"
8"-LFL-011001301-101CH2F-N
29
35
PZV 0078 A
3/4" V
ZC 0301
RESET
3"L4" 14.92
X
ZC 0101
2mm 27
3/4"
26
FROM 011-G-0001-A/B8252
FB LC NOTE 3
FB LO NOTE 3 551
25
101CH2F 103CS1P
21 20
FYV 0175
FT 0175
+
1/2"
3"
MIN.
11
S
ZC
FHSR
0397
0175
0418
0322
0332
0337
ZC
ZC
ZC
ZC
0371
0372
0377
0378
PB RESET
ZC 0397
26
ZC 0397
25 24
10ø MIN. TI 0001
PI 0001
HH
H
TI
23
PI 0140
L
22
LL
0170 21
TT
TT
0001
0170
PT 0001
DETAIL "A"
3/4"
PI 0299
3/4"
PT 0140
3/4"
20 19
INST. PIPING
18
2"
2"
6"x3"
FC
3/4"-SLP-011001003-103CS1P-N
12
0001
STOP PUMPS
CRUDE TO 011-G-0001-A/B
+
16
13
XXXX
STOP PUMPS
FV 0175 6"x3"
14
ZC
DE
17
15
ZC
8"x6"
3/4"
6"x3"
3"
6"x3"
NC HOLD 1
10
SC
8"-SLP-011098002-103CS1P-N
2" NOTE 1
3/4"-SLP-011001004-103CS1P-N
1/2"
ZC
ATM
INST. PIPING
18
ZC
MIN.
19
XIS
3/4"
FC 0175
22
XIS
8"-SLP-011001002-103CS1P-N
23
3632
3/4"-SLP-011001001-103CS1P-N
17 16 15 14 13 12
3/4"
11
D
011-SC-0051
10
TYPE 23 NOTE 6,7
9
28 27
NOTE 5
24
CRU
MIN.
38
39
103SC1P 103CS1P
1"-CHP-011053001-103SC1P-N
REMOVABLE ELBOW 3"
39
9
8
8
7
7
MIN.
NC
1"
FI 0121
3/4"
6
6
MIN.
D 5
5
2"x3/4"
SLOPS FROM STORAGE DS011-TRJR-480134 2677
25 4798
2
2"-CHP-011053001-103SC1P-N 1
DEMULSIFIER FROM 011-X-0003
06
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
05
06-OCT-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
04
04-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
CRUDE OIL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
FROM STORAGE
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
DS011-TRJR-480133 2659
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
ARV / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1- TIE-IN ANTI-FOULING AGENT. 2- MAKE CONNECTION ON TOP OF PIPE. 3- GATE VALVE SHALL BE INSTALLED WITH STEM IN OR BELOW THE HORIZONTAL POSITION AS REQUIRED. 4- MECHANICAL LINK. 5- STEAM SHEDDING LOGIC IN CASE OF GENERAL POWER FAILURE. 6- SET PRESSURE OF PZV-0078 A/B HAS BEEN READJUSTED BASED ON AN ELEVATION FROM PIPE TOP TO PZV. THIS DIFFERENCE OF ELEVATION SHOULD NOT BE HIGHER THAN 18 METER. 7- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM : SA-JER-DS011-TRJR-480275.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
3
2"x1"
18"-CRU-011098001-103CS1P-N
1
2"-CLD-011001307-101CH2S-N
2
103CS1P 101CH2S
250 mm MIN.
3
4
6"-SLP-011098002-103CS1P-N
4
DS011-TRJR-480125 2693
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE FEED INLET
Item Tags :
011-075 011-080
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480001 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480001 2271-011-PID-0021-001
REV: 06
Sheet: 1 of 3
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
35 8252
34
10"-CRU-011001002-103CS1P-N
CRUDE TO 011-G-0001-A/B RECIRCULATION
+
36
10"x8" 8"
10"x8"
10"-CRU-011001017-106CS1P-N
35
MIN.
36
37
FV 0002
106CS1P
103CS1P
37
FO NOTE 7
34
33
33
MIN.
3/4"-CRU-011001010-106CS1P-N
32
32
3/4" 31
31
MIN.
D 2"x3/4"
30
30
250 mm MIN.
106CS1P 101CH2S
29 28
2"-CLD-011001303-101CH2S-P
PI
0002 A
0002
L
25
HS
0001
0009 A
25
PT
FT
0002 A
0002
0001
INST. PIPING
1/2"
INST. PIPING 3/4"
SC 1/2"
NOTE 6 TYPE 1
26
011-SC-0001
1/2"
25
PV 0007
3/4"-CRU-011001020-106CS1P-H
24
16"-CRU-011001005-106CS1P-N
+
3/4" D
22
CRUDE 3632 BL. STORAGE
18"-CRU-011098001-103CS1P-N
1"
STOP PUMPS FI 0002 B
ZC 0397
MIN.
2"x3/4"
6
PIPING INST. 3/4"
0135
3/4" 3/4"
MIN. MIN. 18" NOTE 1
5
2"
4
PI 0003
3/4"
12" 16"x12"
3/4" VENT
/4" 2"x3
M
3
011-G-0001-A
12"-SLP-011098019-103CS1P-H NOTE 9
PI
MIN.
UC NOTE 2
PIPING INST. 3/4"
PI 0137
15 14
25
13
4820
103CS1P 101CH2S
12 11
2"-CLD-011002309-101CH2S-P
10 25
9
7713
INST.
NOTE 2
NOTE 3
17
8
PI 3/4" 3/4"
0004
MIN. 3/4" 3/4"
MIN. NOTE 1
2"
12" 16"x12"
VENT
18"
011-G-0001-B
/4" 2"x3
M
NOTE 5
2"-CRU-011001013-106CS1P-N
7
18"-CRU-011001004-106CS1P-N
8
LPT 2"
2"-CRU-011001012-106CS1P-N
9
UC
INST.
10
3/4" D
2"
2"-CLD-011001304-101CH2S-N
D
MIN.
MIN.
19
16
106CS1P 101CH2S 2"
MIN.
20
2"-SLP-011002001-103CS1P-H
LL
PIPING
LPT
MIN.
NOTE 3
16"x8"
18
D
106CS1P 103CS1P
MIN. 3/4" D
18"-CRU-011001003-106CS1P-N
11
MIN.
8" NC
MIN.
3/4"-CRU-011001011-106CS1P-N
D
2"-FLO-011001304-101CS1P-N
2195
2"-CRU-011001003-106CS1P-N
PIPING
2196
FLO
101CS1P 106CS1P
MIN. FLO
2"-FLO-011001303-101CS1P-N
101CS1P 106CS1P
13
22
16"x8"
2"-CRU-011001004-106CS1P-N 14
FO
3/4"
103CS1P 106CS1P
15
PIPING INST.
FT 0002 B
103CS1P 106CS1P
18"-CRU-011098001-103CS1P-N
16
16"-CRU-011001005-106CS1P-H CRUDE 23 3635 TO 011-E-0001
MIN.
18
16"x12"
250 mm MIN.
19
1/2"
1/2"
MIN.
20
24
21
16"-CRU-011001016-106CS1P-N
21
12"
16"x12"
DV
MIN.
23
12
29
27
FT
INST. PIPING 1/2"
4802
17
NOTE 8
FC
28
27 26
H
FC
7 6 5 4 3
NOTE 5 2"-CRU-011001012-106CS1P-N
2"-CRU-011001013-106CS1P-N
SIGNAL
2
2
FROM PY-0007
DS011-TRJR-480015
MIN.
250 mm MIN.
0001 A 2"-CLD-011001309-101CH2S-N
TYP. 3 106CS1P 101CH2S
MG 0001 B
2"-CLD-011001308-101CH2S-N OLW
25 2831
011-G-0001-A / B CRUDE CHARGE PUMPS
25
3/4"-OLW-011001304-101CS1P-N
OLW START-UP LINE
2830
FROM E-0037 INLET
INSULATION: N
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1- PROVIDE A STRAIGHT LENGHT OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 2- CHECK VALVE SHALL BE INSTALLED HORIZONTALLY. 3- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE.
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
m³/h barg bar barg °C kg/m³
011-G-0001-A / B CENTRIFUGAL 1485.0 33.80 32.50 50.00 40.00 874.0
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
1
NOTE 4
106CS1P 101CS1P
106CS1P 101CH2S
3/4"-OLW-011001303-101CS1P-N
MCC
MIN.
TYP. 3
3633
MIN.
250 mm MIN.
MCC
MG
ZC 0397
NOTE 4
106CS1P 101CS1P
ZC 0397
MIN.
1
4- DISMOUNTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION. 5- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JER-DS011-TRJR-480244. 6- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS011-TRJR-480273. 7- PROVIDE MECHANICAL STOP AT 110% CV NORMAL. 8- HS-0009A AND HS-0009B WILL CHANGE THEIR POSITION SIMULTANEOUSLY TO CONTROL CRUDE INLET FLOW RATE TO THE UNIT TRHOUGH PV-0007 AND DESALTER PRESSURE TRHOUGH FV-0006. 9- START-UP RECIRCULATION LINE. 10- DELETED
DS011-TRJR-480136 7716
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
DFI / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
ARV / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080 011-077
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE CHARGE PUMPS
011-G-0001-A/B ORIGINAL SIGNED IN PROJECT FILE
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480002 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480002 2271-011-PID-0021-001
REV: 05
Sheet: 2 of 3
SCALE: NONE Format:
A1
41
41
40
011-E-0001 FRESH CRUDE/KERO EXCHANGER
011-E-0002 FRESH CRUDE / HAGO EXCHANGER
INSULATION (SHELL/TUBE): H / H
INSULATION (SHELL/TUBE): H / H
40
39
39
TI 38
0004
38
TI 0005
37 36
37 36
TT 0004
TT
35
35
0005
2" 34
34
2"
33
CRUDE TO 011-E-0003 3637 33
32
32
31
31
16"-CRU-011001007-106CS1P-H
20"x16" 8"
29
B2
TI
28
6"
20"
A1
011-E-0001
0002 B1
27
8"
A2
A3
16"
NOTE 4
16"
26
24
29
20" A1
B2
28
011-E-0002 B1
6"
A3
A2
16"
NOTE 4 27
16"
26
LPT 25 24
16"-CRU-011001005-106CS1P-H CRUDE 3635FROM 011-G-0001A/B
MIN.
2"
MIN.
23
LPT
TT 0002
25
30
20"x16"
16"-CRU-011001006-106CS1P-H
30
23
10ø MIN.
106CS1P 106CS2P
16 15 14
3/4"
13
2"
106CS1P 101CH2S
25
PIPING
11
INST.
2529
LPT
2"
18 17
MIN.
D 12
19
MIN.
16
106CS1P 101CH2S
15
250 mm MIN.
2"-CLD-011001301-101CH2S-P
17
2"-CRU-011001023-106CS1P-P
18
MIN.
20
2"-CLD-011001313-101CH2S-P
19
21
MIN.
20
250 mm MIN.
21
2"-CRU-011001022-106CS1P-P
22
4"-PRW-011001001-106CS1P-H
22
14 13
25 2597
12
LPT 11
1/2"
NOTE 3
10
1/2"
9
FT
FC
0139
0139
MIN.
MIN. 10 9
2"
8
TT 0003
TI 0003
H
2"
TT 0006
8
TI 0006
7
7
6
6
5
2"
DESALTING WATER
KEROSENE
FROM 011-E-0032
FROM 011-E-0008
DS011-TRJR-480107 2697
DS011-TRJR-480009 2704
SIGNAL TO FY-0139
DS011-TRJR-480058 3636
2"-CLD-011001310-101CH2S-P
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VDK / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
RDP / MAC
JAL
IFD: ISSUED FOR DESIGN
ARV / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
HAGO
HAGO
01
11-JUN-2010
AFC
FROM 011-E-0009
TO 011-A-0004
00
11-DEC-2009
IFD
DS011-TRJR-480058 2794
DS011-TRJR-480010 2795
DS011-TRJR-480061 2796
1,2, DELETED. 3- CHECK VALVE SHALL BE MOKVELD TYPE IN ORDER TO HAVE DIFFERENT TYPE FROM THE ONE AT PUMP 011-G-0021 DISCHARGE. 4- H.V. @ 150ºC SHELL AND TUBE SIDE.
NOTE 4
2
KEROSENE
NOTES
IN/OUT IN/OUT
3
TO 011-E-0023
4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
MIN. 25
3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED.
SHELL/TUBE SHELL/TUBE
2"-CLD-011001312-101CH2S-P
2528
2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
011-E-0002 AJS 29.20 11.20 50.40 155.00 56.80 95.00 50.00 38.50 100.00 205.00 194.5 3.54
103CS1P 101CH2S
25
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001).
011-E-0001 AJS 30.10 10.40 40.00 145.00 50.40 70.00 50.00 38.50 95.00 175.00 408.1 5.59
4
D
2"x3/4"
2595
GENERAL NOTES
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
6"-HFO-011001001-103CS1P-P
MIN.
6"-HFO-011005001-103CS1P-H
1
D
103CS1P 101CH2S
3/4"
3/4"-HFO-011001002-103CS1P-P
250 mm MIN.
2
8"-JET-011001001-103CS1P-H
3
8"-JET-011005001-103CS1P-H
4"-PRW-011042005-106CS2P-H
2"-JET-011001002-103CS1P-P
250 mm MIN.
MIN. 4
5
MIN.
REV
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 FRESH CRUDE EXCHANGERS
011-074 011-076 011-075 011-080
Item Tags :
011-E-0001
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
011-E-0002
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480003.pid
Discipline: PRO
SA-JER-DS011-TRJR-480003 2271-011-PID-0021-001
REV:
05
Sheet: 3 of 3
SCALE: NONE Format:
A1
41
41
INSULATION (SHELL/TUBE): H / H
2"-FLO-011002301-101CS1P-N
2"-CRU-011001007-106CS1P-N MIN.
3/4" D
39
FLO
2"-CRU-011001007-106CS1P-N
2255
3/4"
40
2"-FLO-011002302-101CS1P-N
MIN.
FLO
106CS1P 101CS1P
40
106CS1P 101CS1P
011-E-0003-A / B/ C/ D FRESH CRUDE/CDU OVERHEAD EXCHANGER
D
2256
39
38
38
LPT 16"x12" NOTE 1 16"x12"
16"x14" 14" FO NOTE 5
106CS1P 101CH2S
16"x12"
106CS1P 101CH2S
2"-CLD-011002308-101CH2S-N
2"-CLD-011002307-101CH2S-N
7711
TT
0066
0066
2"-CLD-011002306-101CH2S-N
2"
25
12"x10"
10"-CRU-011001007-106CS1P-H
12"x10"
NC
NC
12"x10"
28"x18"
40"x28"
LO
LO
NOTE 1
28"x18"
18"-NAP-011018001-101CH2S-P
28"x18"
CL300
3/4"
B1
B2
18"
10" TT
TI
0007
0007
2"
15
011-E-0003-B
CL300
12"x10"
NOTE 1
14
10"
3/4"
18"
10"
2"-CRU-011002010-106CS1P-P
TT 0008
2"-CRU-011002009-106CS1P-P
TI 0008
D
CL300
10"
18"
CL300
TT 0009
MIN.
NOTE 4
18
10"
18"
2"
TT
TI
0010
0010
NOTE 1 12"x10" 10"-CRU-011002002-106CS1P-H LPT
16"x12" NOTE 1 16"x12" LO LO
10"
B1
TI 0009
10"-CRU-011002002-106CS1P-H
20 19
A1
B2
12"x10"
12"-CRU-011002002-106CS1P-H
A2
NOTE 4
B1
B2
011-E-0003-D
18"
CL300 A1
2"
LPT
13
A2
NOTE 4
B1
2"
10"-CRU-011002002-106CS1P-H 12"x10"
25 4834
011-E-0003-C 10"
18"
CL300
UC A1
B2
D
16
18" A2
NOTE 4
MIN.
17
10" A1
18"-NAP-011018001-101CH2S-P
NOTE 1 CL300
12"-CRU-011002002-106CS1P-H LO
22 21
18"-NAP-011018001-101CH2S-P
UC
23
LO
17
10"-CRU-011002001-106CS1P-H
A2
18
2"-CLD-011002305-101CH2S-N
MIN.
011-E-0003-A
25
HPT
MIN.
18"
CL300
12"x10" 10"-CRU-011001007-106CS1P-H
28"-NAP-011018001-101CH2S-P
NOTE 1 19
106CS1P 101CH2S
NOTE 1 HPT
28"x18"
26
3/4"
24
10"-CRU-011001007-106CS1P-H 40"x28"
28 27
2"
10"-CRU-011001007-106CS1P-H
28"-NAP-011018001-101CH2S-P
18"-NAP-011018001-101CH2S-P
0078
2"-NAP-011002009-101CH2S-P
21 20
0078
3/4"-CRU-011002005-106CS1P-N
NOTE 1
22
TI
2"x3/4"
5318
23
TT
V
V
25
24
3/4"
2" MIN.
30
2" V
101CH2F 101CH2S
MIN. 2"-NAP-011002004-101CH2S-P
FC
29
HPT
MIN.
TI
2"
101CH2F 101CH2S
10"x8"
29
NOTE 3
MIN.
26
250 mm MIN.
106CS1P 101CH2S
27
10"-CRU-011002001-106CS1P-H
5243
V
31
10"x8" 8" MIN.
2"-LFL-011002301-101CH2F-N
MIN.
2" 28
32
HV 0001
HPT
3/4" 2"x3/4"
33
25
25 7712
30
HPT
34
+
NC 3/4"-CRU-011002008-106CS1P-N
HC 0001
2"
16"x12"
31
29
35
D
MIN.
2"
32
2"
2"-CRU-011002012-106CS1P-P
MIN.
33
36
D
MIN.
16"x14"
37
MIN.
250 mm MIN.
MIN.
16"-CRU-011001007-106CS1P-H
LO 2"
2"-CRU-011002011-106CS1P-P 2"
+
35
CRUDE 3637 FROM 011-E-0002
2"
HV 0003
LO
MIN.
HC 0003
LO
250mm MIN.
36
LO
250mm MIN.
MIN.
12"-CRU-011001007-106CS1P-H
MIN.
MIN.
12"-CRU-011001007-106CS1P-H
37
34
LPT
16 15 14 13
12
12
TW
0081
0086
2" CL300
TW 0088
2" CL300
2" CL300
8
CP
CP
6
106CS1P 101CH2S
2"-CLD-011002303-101CH2S-P
0011
011-SP-0154 2"
9
CP
NOTE 2 8
TT
6
2"
3036
25
16"-CRU-011002002-106CS1P-H
CRUDE TO 011-E-0004
3043
10 ø MIN.
TI
2" CL300
18"-NAP-011002001-101CH2S-P
2" 34"x24"
24"-NAP-011002001-101CH2S-P
34"x24"
NOTE 1
LO
011-SP-0155 MIN.
D
250 mm MIN.
2"
2"-CLD-011002302-101CH2S-P
CP
2"-NAP-011002003-101CH2S-P
2"-CLD-011002304-101CH2S-P
CDU OVERHEAD TO 011-A-0001 DS011-TRJR-480045 2814
25 3044
3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1- SYMMETRICAL ARRANGEMENT. 2- CORROSION PROBE. 3- MAKE CONNECTION ON TOP OF PIPE. 4- H.V.@ 150°C SHELL AND TUBE SIDE. 5- PROVIDE MINIMUM MECHANICAL STOP AT 70.8% OF NORMAL FLOW WITH PRESSURE DROP OF 0.8 BAR TO AVOID LOSS OF CONTROL ON PV-0007. 6- DELETED. NOTE 4
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JVM / STG
RDP / MAC
JAL
25 REV
3038
2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
IN/OUT IN/OUT
D
NOTE 2
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001).
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
2
2"
GENERAL NOTES
SHELL/TUBE SHELL/TUBE
3
TI 0192
MIN.
34"-NAP-011002001-101CH2S-P
2"
2"-NAP-011002002-101CH2S-P
DS011-TRJR-480043 2797
011-E-0003-A / B/ C/ D AES 28.30 1.00 56.80 119.20 79.70 98.60 50.00 38.50 115.00 160.00 1937.7 13.00
2" CL300
LPT
4
18"-NAP-011002001-101CH2S-P
MIN.
MIN.
CDU OVERHEAD NAPHTHA FROM 011-C-0002
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
NOTE 1 24"x18"
24"-NAP-011002001-101CH2S-P
LO
MIN.
24"x18"
18"-NAP-011002001-101CH2S-P
3638
1
40"-NAP-011018001-101CH2S-P
1
UC
2"
LPT
0191
2
UC
250 mm MIN.
3
24"x18" NOTE 1 24"x18"
18"-NAP-011002001-101CH2S-P
5
MIN.
NO POCKET
4
7
0011 25
5
10
TI
D
NOTE 2
250 mm MIN.
106CS1P 101CH2S 2"-CLD-011002301-101CH2S-P
7
CP
NOTE 2
NOTE 2
2"
2"
11
2"
011-SP-0153
011-SP-0152
MIN.
2"
2" D
2"-CRU-011002003-106CS1P-P
011-SP-0151
9
MIN.
2"-CRU-011002004-106CS1P-P
MIN.
10
TW 0090
MIN.
TW
250 mm MIN.
2" CL300 11
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 011-075 011-080 011-077
Item Tags : 011-E-0003-A/B/C/D
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE PREHEAT - CDU OVERHEAD ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480004.pid
Discipline: PRO
SA-JER-DS011-TRJR-480004 2271-011-PID-0021-002
REV:
05
Sheet: 1 of 1
SCALE: NONE Format:
A1
41
41
011-E-0004-A / B FRESH CRUDE/PREFLASH OVERHEAD EXCHANGERS
40
40
INSULATION (SHELL/TUBE): P / H 39
39
16"-CRU-011003002-106CS1P-H
NO POCKETS 38
38
MIN. 2"-CRU-011003002-106CS1P-P HPT 2" V
37
2"-FLO-011003301-101CS1P-N FLO
106CS1P 101CS1P
36
3/4" D 35
36
2253
HPT
35
2"-LFL-011003001-101CH2F-N
29
MIN.
5292
34
NOTE 4 2" 32
101CH2F 101CH2S NC
MIN. 2"
31
2"
MIN. 2"-NAP-011003005-101CH2S-P
2"
TT 0012
3/4" D
MIN. 2"-NAP-011003006-101CH2S-P
V
LO
LO
LO
16" 011-SP-0156
CP
16"x12"
2"-CLD-011003313-101CH2S-P NOTE 3
22
2" CL300
21
TI 0014
2"-CLD-011003314-101CH2S-P
2"
24"x16"
MIN.
NOTE 1
0016
18
0016
MIN. 2"
17
MIN.
D
16 15
UC 2"-CRU-011003010-106CS1P-P
2"-CRU-011003011-106CS1P-P
2"-CLD-011003304-101CH2S-P
3/4" V
3/4"
14 13
25
V
12
2692
LPT
11
LPT
MIN.
LO
LO
16"x12"
TI
12"-CRU-011002002-106CS1P-H LO
LO
0017
MIN.
16"x12" 10
NOTE 1
TV 0016
8
TT
+
0017 10"-CRU-011003001-106CS1P-H 2"
2"-CLD-011003316-101CH2S-P
25 2689
25
MIN.
3/4"
4
10" 106CS1P 101CH2S
NOTE 3 2"-CLD-011003303-101CH2S-P
3
NC 2
MIN. 3/4" 3/4"-CRU-011003006-106CS1P-P 2"x3/4"
25
D
2691
16"-CRU-011002002-106CS1P-H
106CS1P 101CH2S
1
2"-CLD-011003305-101CH2S-P PREFLASH OVERHEAD TO DRUM 011-D-0003
25
DS011-TRJR-480023 2848
4843
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 2, DELETED. 1- SYMMETRICAL ARRANGEMENT. 3- CORROSION PROBE. 4- MAKE CONNECTION ON TOP OF PIPE. 5- H.V. @ 150° C SHELL AND TUBE SIDES. 6- DELETED.
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-E-0004-A / B AES 3.50 24.90 132.70 85.20 107.40 97.00 5.00 50.00 175.00 130.00 1489.0 6.95
NOTE 5
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
6
CRUDE TO 011-E-00053639 5
CP
10776
PREFLASH OVERHEAD FROM COLUMN 011-C-0001 DS011-TRJR-480020 2847
2" 16"-CRU-011003002-106CS1P-H
MIN.
1
2"-CLD-011003301-101CH2S-P
10ø MIN.
250mm MIN.
2
106CS1P 101CH2S
011-SP-0158 106CS1P 101CH2S
FC
D
2"-CRU-011003005-106CS1P-P 24"-NAP-011003001-101CH2S-P
3
MIN.
24"-NAP-011011001-101CH2S-P
4
MIN.
250mm MIN.
2"-CRU-011003015-106CS1P-P
5
2" MIN.
2"-CRU-011003004-106CS1P-P
2"
MIN.
D
MIN.
6
7
10" MIN.
MIN.
250mm MIN.
7
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
10 9
MIN.
8
21
TC
2690
11
CL300
TI 0015
20
2"-NAP-011003003-101CH2S-P
25
2"
19
UC
12
NOTE 3
7690
TT
D
2"-CLD-011003302-101CH2S-P
23
CP 16"x12"
250mm MIN.
13
2"
MIN
14
011-SP-0157
LO
CL300
MIN.
15
24
16"
16"
16"-NAP-011003001-101CH2S-P
MIN.
16
2"-NAP-011003002-101CH2S-P
B2
A1
25
LPT
24"x16"
2"
250mm MIN.
12"-CRU-011002002-106CS1P-H
17
A2
22
2"
25 7693
MIN.
26
UC
19 18
MIN.
106CS1P 101CH2S
LO
20
16"
B1
25
UC LPT
16"
D
27
MIN.
23
106CS1P 101CH2S
29
011-E-0004-B
16"x12"
2" 2"-CRU-011003014-106CS1P-P
10ø MIN.
16"
B2
MIN.
HPT
MIN.
D
A2
2"
TI 0013
16"-NAP-011011001-101CH2S-P
250mm MIN.
A1
LO
TT 0013
28
2"
25 24
24"x16" NOTE 1
LO
HPT
MIN.
2"-CRU-011003013-106CS1P-P
16"
B1
9
LO
MIN.
16"
26
CRUDE 3638FROM 011-E-0003
30
250mm MIN.
011-E-0004-A
16"x12"
24"x16"
32
16"x12" NOTE 1
MIN.
16"-NAP-011011001-101CH2S-P 27
2254
MIN.
LPT 16"x12"
2"
28
33
FLO
31
12"-CRU-011003002-106CS1P-H
MIN.
TI 0012
29
101CH2F 101CH2S NC
2" LPT
MIN.
2"-FLO-011003302-101CS1P-N
MIN.
V
30
HPT
MIN.
33
34
2" V 2"-CRU-011003002-106CS1P-P 106CS1P 101CS1P
37
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
DFI / STG
RDP / MAC
JAL
00
11-DEC-09
IFD
IFD: ISSUED FOR DESIGN
MVF / FCB
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
COMPANY STATUS
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY 011-078
PIPING AND INSTRUMENT DIAGRAM
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 FRESH CRUDE - PREFLASH OVERHEAD EXCHANGERS
Project:
011-074 011-076 011-075 011-080 011-077
Item Tags :
011-E-0004-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480005 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480005 2271-011-PID-0021-003
REV: 05
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
40
40
011-E-0005 FRESH CRUDE / LVGO PA EXCHANGER
39
39
INSULATION (SHELL / TUBE): H / H
38
38
37
37
36
36
35
35
34
34
LO LO
33
33
LPT
32
MIN.
32 31
31
MIN.
30
25 24
3/4"
20"x16"
2"-DIE-011003002-103CS1P-P
V
26
2"
25
LO
5294
12"x10"
2"
D B2
A1
12"
103CS1P 101CH2S
12"x10"
2"-CLD-011003315-101CH2S-P
20" 20"x16" 16"-CRU-011003007-106CS1P-H
17
7717
2"
TT 0018
15
TI 0018
14
2" MIN.
250 MIN.
UC
2"-CLD-011003309-101CH2S-P
13
LPT 2"-DIE-011003003-103CS1P-P
2"-CRU-011003012-106CS1P-P
106CS1P 101CH2S
12
2"
3/4" V 2"
11
V
HPT
MIN.
MIN. D LO
8
2"-DIE-011003003-103CS1P-P
9 8 7
6375
103CS1P 101CH2S
6
6
250 MIN.
2"-CLD-011003312-101CH2S-P MIN.
16"-CRU-011003002-106CS1P-H
4
10
TI 0179
LO
25
7
TT 0179
2"
2"
LO
9
CRUDE 3639 FROM 011-E-0004-A/B
16
25
2"-CRU-011003008-106CS1P-P
10
18
LPT
MIN. D
11
CRUDE 19 TO 011-E-00063640
2"-CRU-011003008-106CS1P-H
13 12
16"-CRU-011003003-106CS1P-H
MIN.
14
20
2"
MIN.
MIN.
15
21
250mm MIN.
NOTE 3
19
2"
2"-DIE-011003004-103CS1P-P A2
011-E-0005 20
TT 0019 MIN.
12"
B1
16
23
MIN.
20"
17
24
22
21
18
TI 0019
25
D
22
5
27
3/4"
MIN.
26
28
106CS1P 101CH2S
MIN.
27
23
MIN.
D
D
29
UC
250mm MIN.
3/4"
2"-CLD-011003310-101CH2S-P
28
2"-CRU-011003003-106CS1P-P
16"-CRU-011003003-106CS1P-H
7718
2"-FLO-011003303-101CS1P-N 101CS1P 106CS1P
FLO
29
30
2"-CRU-011003009-106CS1P-P 2"
5 4
3
3
25 7719
2
10"-DIE-011003001-103CS1P-P
2"-CRU-011003016-106CS1P-P MIN.
1
MIN.
2" D
10"-DIE-011037003-103CS1P-H
2
106CS1P 101CH2S
1
2"-CLD-011003317-101CH2S-P
IN/OUT IN/OUT
NOTE 3
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
15-DIC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
LVGO PA
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
RDP / MAC
JAL
25
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MRM / FCB
RDP / MAC
JAL
10777
DS011-TRJR-480097 2849
DS011-TRJR-480096 2850
PREPARED BY
CHECKED BY
1,2 DELETED. 3- H.V. @ 150ºC SHELL AND TUBE SIDE. 4- DELETED.
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
AB: AS BUILT
FROM 011-G-0015
NOTES
SHELL/TUBE SHELL/TUBE
AB
LVGO PA
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAIN SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
011-E-0005 AES 12.00 22.30 141.00 91.60 117.20 100.00 38.50 50.00 190.00 135.00 667.0 5.00
13-MAR-2013
TO 011-A-0005
GENERAL NOTES
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
05
REV
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE PREHEAT - PREFLASH TOP AND LVGO PA
011-074 011-076 Item Tags :
011-075 011-080
011-E-0005
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480006 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480006 2271-011-PID-0021-003
REV: 05
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
41
011-E-0006 FRESH CRUDE/LAGO EXCHANGER
40
40
INSULATION (SHELL / TUBE): H / H 39
39
38
38
37
37
36
36
TI 0027
35
35
34
34
33
33
TT 0027
32
32
2" 31
31
16"-CRU-011004001-106CS1P-H
30
30
29
29
6"-DIE-011009001-103CS1P-H 28
28
27
27
20"x16" 26
8"x6"
20" B1
25
26
8"
011-E-0006
A2 B2
A1
24
25
NOTE 4 24
8"
20" 23
23
20"x16" 22
8"x6" 22
MIN. 3/4"-DIE-011004002-103CS1P-H
LPT
21
21
16"-CRU-011004001-106CS1P-H 20
2"
LPT 16"-CRU-011003003-106CS1P-H
TT 0026
TI 0026
19
MIN.
CRUDE 19 3640FROM 011-E-0005
CRUDE TO 011-E-0007 A/B/C/D 3641 20
18
18
3/4" 17
17
3/4" MIN.
12
15
MIN.
11
2" D
6 5
12 11 10 9
103CS1P 101CH2S
2"-CLD-011004307-101CH2S-P
7
106CS1P 101CH2S
250 mm MIN.
2"-CLD-011004310-101CH2S-P
8
13
2"x3/4"
10 9
14
MIN.
13
16
4 3
8 7
250 mm MIN.
14
D
3/4"-DIE-011004002-103CS1P-P
15
MIN.
2"-CRU-011004006-106CS1P-P
16
6 5 4 3
25 5301
2
2
6"-DIE-011004001-103CS1P-H
5299
6"-DIE-011009001-103CS1P-H
25 1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
LAGO
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
DFI / STG
RDP / MAC
JAL
TO 011-E-0024
FROM 011-E-0011
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JGT / JLM
RDP /MAC
JAL
DS011-TRJR-480110 2851
DS011-TRJR-480017 2852
REV
DATE
COMPANY STATUS
LAGO
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1,2,3, DELETED. 4- H.V. @ 150ºC SHELL AND TUBE SIDE.
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-E-0006 AES 12.30 21.20 171.00 97.00 109.00 104.00 38.50 50.00 205.00 140.00 635.0 4.25
NOTE 4
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
1
05
13-MAR-2013
AB
04
30-SEP-2011
03
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080
011-E-0006
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE PREHEAT - LAGO ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480007 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480007 2271-011-PID-0021-004
REV: 05
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
011-E-0007-A / B / C / D FRESH CRUDE/KERO PA EXCHANGERS
40
INSULATION: SHELL / TUBE: H / H TRIM: CRU-011004601-106CS1P TRIM: JET-011004601-103CS1P
39 38
40 39
12"-CRU-011004002-106CS1P-H TW 0020
2"
38
12"-JET-011026001-101CS1P-H
37
37
14"x12" 14"
36
12" A3
B2 35
CL300
36
011-E-0007-A
B3
A2
35
34
34
12" CL300
0269
30
A4
011-E-0007-B B4 12" CL300
A1
14"
28
LPT
D
TT PDV 0449
CL300
FO CL300
16"x12"
D
16"x12"
19
16"-JET-011004001-101CS1P-H
LPT
MIN
106CS1P 101CH2S
18
A2
MIN. D
MIN.
101CS1P 101CH2S 2"-CLD-011004304-101CH2S-P 250mm MIN.
2" D
D
25
106CS1P 101CH2S
12
2"-CLD-011004305-101CH2S-P
101CS1P 101CH2S
2524
250 mm MIN.
13
2"-CLD-011004306-101CH2S-P
18
6062
17
2" B1
16
0272
A1 14"
15
011-E-0007-D
A4
14
B4 12" CL300
14"x12"
13
CL300
TW 0023
12
12"-JET-011004001-101CS1P-H
12"-CRU-011004001-106CS1P-H
2525
10
PIPING
9
INST.
3/4" FC 0003
8
TC 0024
7
TV 0024
11 10 9 8 7
+
FT
6
10"x6"
INST. PIPING 1/2"
FV 0003 +
16"x10"
3
10"
1/2"
TT 0024
16"x10"
CL300
FO 2
6"
6
10"x6"
10"-JET-011004002-101CS1P-H
FC CL300
5
MIN
3/4"
3/4"
4
2" 3
10"x4"
MIN.
4
MIN
5
10 ø MIN.
0003
4"
10"x4"
KEROSENE PA
16"-JET-011004001-101CS1P-H
14"x8"
8"
14"x8"
D
2"-CLD-011004302-101CH2S-P KEROSENE PA
MIN.
2"-CLD-011004301-101CH2S-P
TO 011-C-0002
25
25
DS011-TRJR-480043 2870
250mm MIN.
101CS1P 101CH2S
250mm MIN.
101CS1P 101CH2S
2"x3/4" MIN.
D 2"x3/4"
4882
2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND / OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT / PIPING TO BE DRAINED.
NOTES 2- DELETED. 1- SYMMETRICAL ARRANGEMENT. 3- H.V. @ 150ºC SHELL AND TUBE SIDE.
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
NOTE 3
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JGT / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001).
011-E-0007-A - D AES 7.80 20.20 171.30 104.00 122.30 131.70 38.50 50.00 200.00 165.00 2714.0 17.04
05
7845
GENERAL NOTES
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
1
3/4"
3/4" 3/4"-JET-011004003-101CS1P-P
DS011-TRJR-480063 2877
MIN. 3/4"-JET-011004004-101CS1P-P
MIN.
2
FROM 011-G-0008 A/B
NC 1
19
TW
25
2601
25
12" CL300
14" CL600
5315
25
20
25
2"-CLD-011004309-101CH2S-P
250mm MIN.
MIN.
14
2" MIN.
2"-CRU-011004004-106CS1P-P
101CS1P 101CH2S
B3
2"
250mm MIN.
17
2"-JET-011004005-101CS1P-P
21
2"-CLD-011004311-101CH2S-P TW 0271
22
011-E-0007-C
2"
LPT
16
CL300 12" A3
NOTE 1 16"x12"
D
2"x3/4" B2
2"
23
16"-JET-011026001-101CS1P-H
NOTE 1
3/4"-JET-011004007-101CS1P-P
12"-JET-011026001-101CS1P-H
14"
MIN.
MIN. MIN.
16"-CRU-011004001-106CS1P-H CRUDE 20 3641FROM 011-E-0006
24
14"x12"
16"x12"
16"x12"
25
16"x10"
3/4"
2"-JET-011004006-101CS1P-P
21
16"x12"
MIN.
2"-CRU-011004003-106CS1P-P
26
MIN.
0021
22
27 16"-CRU-011004002-106CS1P-H CRUDE TO 011-E-00083642
12"-CRU-011004002-106CS1P-H
2"
TW
23
2" 10 ø MIN.
3/4" 10"
28
16"x12" NOTE 1
NOTE 1
TW 0022
16"x10"
MIN.
24
10" 16"x10"
16"x10"
12"-JET-011004001-101CS1P-H
25
3/4"
INST PIPING
29
0025
250mm MIN.
MIN.
2" CL300
LPT
30
2"
16"x12"
31
PDC 0449
+
12"-CRU-011004001-106CS1P-H
26
TT
32
TI 0025
0244
14"x12"
27
11
TW 0270
3/4"
B1
29
15
2"
2"
TW
31
UC
TI 0244
33
MIN.
14" CL600
32
PDT 0449
2"-JET-011004008-101CS1P-P
33
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE HPW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN H.P. NITROGEN L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE PREHEAT - KERO PA
011-074 011-076 Item Tags :
011-075 011-080
011-E-0007 A/B/C/D
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480008.pid
Discipline: PRO
SA-JER-DS011-TRJR-480008 2271-011-PID-0021-004
REV:
05
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
41
011-E-0008 FRESH CRUDE / KERO EXCHANGER
40
40
INSULATION (SHELL/TUBE): H/H 39
39
38
38
37
37
36
36
35
16"-CRU-011005001-106CS1P-H
34
CRUDE TO 011-E-0009-A/B 3643
35 34 33
33
20"x16" 32
011-E-0008
20" B2
31 30
32
NOTE 3
8" A1
31
B1
A2 20"
30
8"
29
29
20"x16" 28
16"-CRU-011004002-106CS1P-H
CRUDE
27
3642FROM 011-E-0007 A/B/C/D
MIN.
27
28
LPT
26
26 25
25
TI 0028
2"-CRU-011005013-106CS1P-P
24 23 22 21 20
TT 0028
24
2" 23 22 21 20
LPT
2" D
19
2"-JET-011005002-103CS1P-H
MIN.
19
MIN.
18
18
106CS1P 101CH2S
15 14 13
17
2"-JET-011005002-103CS1P-P
16
250 mm MIN.
2"-CLD-011005307-101CH2S-P
17
16 15 14 13
2" D
25 11
12
MIN.
12 5305
2" 103CS1P 101CH2S
9 8 7 6
TI 0207
11 10 9
250 mm MIN.
2"-CLD-011005308-101CH2S-P
10
TT 0207
8 7 6
5
5
4
4
25 5308
3
3 2
8"-JET-011005001-103CS1P-H
1
8"-JET-011022006-103CS1P-H
2
KEROSENE
KEROSENE
TO 011-E-0001
FROM 011-G-0009
DS011-TRJR-480003 2704
DS011-TRJR-480053 2888
1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
DFI / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MVF / FCB
RDP / MAC
JAL
PREPARED BY
CHECKED BY
APPR/AUTH BY
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1,2, DELETED. 3- H.V @ 150ºC.
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-E-0008 AES 11.80 17.40 213.60 131.70 145.00 140.50 38.50 50.00 255.00 170.00 710.5 5.74
NOTE 3
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
REF. DWG
011-075
JUBAIL EXPORT REFINERY 011-078
PIPING AND INSTRUMENT DIAGRAM Project:
011-074
011-076 011-075 011-080
Item Tags :
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE PREHEAT - KERO
011-E-0008 ORIGINAL SIGNED IN PROJECT FILE
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480009.pid
Discipline: PRO
SA-JER-DS011-TRJR-480009 2271-011-PID-0021-005
REV:
05
Sheet: 1 of 3
SCALE: NONE Format:
A1
41
NOTE 9 NOTES 11, 12
011-E-0009-A / B FRESH CRUDE/HAGO EXCHANGERS
ZC 0397
+
8"-LFL-011005301-101CH2F-N
29
NO POCKETS
6060
37
BY-PASS POSITIONER 3/4"
36
L
CRUDE 3643FROM 011-E-0008
MIN.
TT 0045
33
2"-FLO-011005301-101CS1P-N
2"-CRU-011005002-106CS1P-P
101CS1P 106CS1P
2205
31
MIN. D
3/4"
30
LPT
18"x12"
MIN.
12"-CRU-011005002-106CS1P-H
29
2"
2"
10ø MIN.
FLO
32
TT 0031
NOTE 6 FB LO NOTE 6 FB LO
OPEN
CLOSED
ZHA
ZYC
ZLO
ZLC
0085
0085
0085
0085
ZHS 0085
40
18"-CRU-011005002-106CS1P-H NOTE 8
38
+
S
IA
ZY 0085
ZLS 0085 O
ATM
ZLS 0085 C
PDT 0005
INST. PIPING
3/4"
3/4" 3/4"
PDC 0005
INST. PIPING
34
TI 0273
3/4"
3/4"
2"
3/4"
3/4"
PDV 0005 +
3/4"
16"
18"x16"
18"-CRU-011005002-106CS1P-H FC TSO
DETAIL "A"
36 35
+
3/4" D
37
NOTE 8
INST. PIPING
18"x16" 31
FO NOTE 8
30
12"-CRU-011005002-106CS1P-H
SIGNAL 011-LDC-0089
MIN.
CL600
14" 14"x12"
2"
CL600
LPT
6"
6"-HFO-011009001-103CL2P-H
250 mm MIN. 25 7750
3/4" NOTE 2
6"-HFO-011005001-103CS1P-H
2" CL600
250 mm MIN.
6"-BRN-011005002-106CS1P-H
MIN. 250mm MIN.
25
21
4901
MIN.
FI 0146
1"
NC
20 19 18
NOTE 7
17
25
16
7751
15 14 13
TI
25
0174
7752
12 11 10
25
25
2527
2599
STOP PUMPS G-0013 A/B CLOSE ZV-0080
6"-HFO-011005001-103CS1P-H
1
HH
ZC
TI
0420
TT
0388
2"-CLD-011005302-101CH2S-P 25 2526
NC
DETAIL "A" 011-E-0009-A / B AES 12.40 16.60 294.00 139.70 160.30 153.80 38.50 50.00 325.00 185.00 787.0 9.10
1" 2mm
REMOVABLE ELBOW 3"
NOTE 10
FLOW
60º
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
D
1"
6"x4"
D
SIGNAL TO 011-TV-0031
DS011-TRJR-480017
DS011-TRJR-480107 2923
DS011-TRJR-480013 2925
4" 6"x4"
4 3
DESALTER BRINE DS011-TRJR-480107 2924
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
RDP / MAC
JAL
IFD: ISSUED FOR DESIGN
NPS / STG
RDP / MAC
JAL
FROM 011-X-0003
00
11-DEC-09
IFD
DS011-TRJR-480017 2910
DS011-TRJR-480125 2922
REV
DATE
COMPANY STATUS
1, 5, DELETED. 2- SYMETRICAL ARRANGEMENT. 3- DESIGNED FOR 50% OF THROUGHPUT FOR MAINTENANCE. 4- MAKE CONNECTION ON TOP OF PIPE. 6- BLOCK VALVE SHALL BE INSTALLED WITH STEM IN OR BELOW THE HORIZONTAL POSITION. 8- SUPPLY BY DESALTER PACKAGE VENDOR AS LOOSE ITEMS. 9- LOCAL EMERGENCY SWITCH BEHIND FIREWALL OR IN SAFE LOCATION. 11- SET PRESSURE READJUSTED BASED ON ELEVATION FROM TOP TL OF E-0009 TO TZV ELEVATION DIFFERENCE SHOULD NOT BE HIGHER THAN 13.9m 12- SPARE TZV TO BE IN WAREHOUSE TO SUPPLY BY SATORP. REFER TO OPERATING MANUAL FOR MAINTENANCE PROCEDURE. 13- DELETED.
UTILITIES IDENTIFICATION 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
1
05
FROM 011-E-0012A/B
POS.
2
TO 011-E-0032
TO 011-E-0002
REVISION MEMO
6 5
NC
DS011-TRJR-480003 2795
10- HALF VACUUM@150°C (SHELL AND TUBE SIDE). X
DESALTER BRINE 6274 FROM 011-D-0001
6"-BRN-011006001-103CS4P-P
DEMULSIFIER
7- VALVE TO BE OPEN ONLY IN CASE OF 011-D-0001 IS OUT OF SERVICE AND THE FOUR (4) BLOCK VALVES SHALL BE CLOSED. 103SC1P 103CS1P
7
4" 6"x4" FC
HAGO
NOTES
VIEW FROM X
+
1"
FROM 011-E-0032
4"-HFO-011009001-103CL2P-H NOTE 3
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
60º
LDV 0089 6"x4"
HAGO
1"
6"-BRN-011006001-103CS4P-P
2ND STAGE DESALTER WATER FROM 011-G-0024
DESALTING WATER
3644
GENERAL NOTES
ø=33.4mm ext.
6"-BRN-011007002-106CS2P-H
250 mm MIN. UC
2600
106CS1P 101CH2S
106CS2P 103CS4P
CRUDE TO 011-D-0001 3897 8
2"-CLD-011005306-101CH2S-P
25
0388
INJECTION QUILL
6"-PRW-011042002-106CS2P-H
MIN.
MIN.
MIN. MIN.
2"
4"-HFO-011005001-103CS1P-H
2"
103CL2P 101CH2S
1"-CHP-011053002-106SC1P-N
0030
2"-CLD-011005305-101CH2S-P
2
TT
2"-HFO-011005009-103CL2P-P
6"-HFO-011009001-103CL2P-H
2"-CLD-011005301-101CH2S-P
2"
2"-HFO-011005007-103CL2P-P
103CS1P 103CL2P
3
V
H
0030
250 mm MIN.
250 mm MIN.
106CS1P 101CH2S
103CL2P 101CH2S
TI
LC
2" D
3/4"
MIN.
5 4
9
250 mm MIN.
MIN.
D 2"-HFO-011005006-103CL2P-P
2"-CRU-011005005-106CS1P-P
2" MIN.
LPT
MIN. 10 ø MIN.
MIN.
2"-CRU-011005004-106CS1P-P
IN/OUT IN/OUT
NOTE 2
22
LPT
MIN.
D
6
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
23
2"
2"
SHELL/TUBE SHELL/TUBE
24
2"
7
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
106CS1P 101CH2S
D
6"-HFO-011005005-103CL2P-H 2"-CLD-011005311-101CH2S-P
V
106CS1P 101CH2S
D
2"
103CL2P 101CH2S
14"x12"
UC
26 25
2"-CLD-011006301-101CH2S-P
250 mm MIN.
B1 CL600
2204
3/4"
A1
14"
D
2"x3/4"
3/4"
D
MIN. 3/4"
16"x12" 12"-CRU-011005001-106CS1P-H
8
3/4"-HFO-011005011-103CL2P-P
CL600
A2
NOTE 10
2"-CRU-011005015-106CS1P-P
NOTE 2
MIN.
011-E-0009-B
103CL2P 101CH2S 2"-CLD-011005312-101CH2S-P
10 9
B2
MIN. 3/4" D
6"
LPT
MIN.
16"x12"
2"
TI 0171
MIN.
10 ø MIN.
0029 11
2"-HFO-011005008-103CL2P-P V 3/4"
6"-HFO-011005004-103CL2P-H
V 3/4"
13
12"-CRU-011005001-106CS1P-H
6" UC
14"
27
3/4"
NOTE 7
B1
A2
HPT
FLO
2"-CLD-011005310-101CH2S-P
14
A1
LPT
MIN.
TI 0029
NOTE 10
CL600
103CL2P 103CS1P
MIN.
16
6"
2" V
V 2" 14"x12"
3/4"
MIN.
17
2"-CRU-011005014-106CS1P-P
B2
011-E-0009-A
3/4" D
103CS1P 103CL2P
14"
18
MIN.
2"-HFO-011009001-103CL2P-P
HPT
LPT
14"x12"
UC
2218
MIN
3/4"-CRU-011006005-106CS1P-P
NOTE 7
TT 0499
103CL2P 101CS1P
D
2" CL600
FLO
2"x3/4"
3/4"
V
2"
HPT
2"
2"-FLO-011005303-101CS1P-N
HPT
19
TT
101CS1P 106CS1P
2"-HFO-011009001-103CL2P-P
20
12
MIN.
29
6275
28
106CS1P 106CS2P
2"-FLO-011005304-101CS1P-N
7749
MIN.
V 2"
2"-CRU-011005017-106CS1P-P
MIN.
TT 0498
103CL2P 101CS1P
21
25
MIN.
22
2" CL600
D
TI 0499
2"-CLD-011005309-101CH2S-P
MIN.
23
LPT
106CS1P 101CH2S
3/4"-HFO-011005010-103CL2P-P
24
3/4" D
MIN.
16"-CRU-011005001-106CS1P-H
0498
3/4"
MIN.
TI 25
MIN.
MIN.
26
2203
2"-CRU-011005002-106CS1P-P
2"-FLO-011005302-101CS1P-N NOTE 13
D
250 mm MIN. MIN.
27
15
FLO
2"-CRU-011005016-106CS1P-P 2"
33 32
18"x16" 16" 18"x16" 28
CRUDE 39 TO OUTLET 6496 011-D-0001
0200
ZYV 0085
ZV 0085
18"x12" NOTE 2
L
ZC 0323
DE
MIN.
34
D
TC 0031
6"-CRU-011005011-106CS1P-H
TI 0045
35
0085 L
PDT
6"x4" H
0085
CL600
LO FB
NOTE 4
ZHSR 0085
+
8"x6"
NOTE 6
0.2%
38
RESET
TZV 0013
V
3/4"
ES ZHXS
MIN.
INSULATION (SHELL/TUBE): H/H 39
ES ZHXS
18"-CRU-011005002-106CS1P-H
40
4"L6" 48.79
41
PDI 0200
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 011-075 011-080 011-077
Item Tags : 011-E-0009-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE PREHEAT - HAGO ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480010 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480010 2271-011-PID-0021-005
REV: 05
Sheet: 2 of 2
SCALE: NONE Format:
A1
011-D-0001 DESALTER
41
NOTE 25
1"x3/4"
39
LC 3/4"-OLW-011006307-101CS1P-N
3/4" D
XL
XL
IT
IT
IT
D0001 L
0041 L
0042 L
0043 L
0041 L
0042 L
0043 L
0323
0398
0379
FB
ZC 0379
0379
LO NOTE 4
1"x3/4"
3/4"-CLD-011006311-103CH2S-H
CLOSED ZV-0110
3/4"X3/4" 0.40 PAH 0354
TZV 0090
PAHH
LALL
ZC
ZC
0328
0142
0318
0319
+
25 SIGNAL 6275 TO LDV-0089
PSH 0354
TI 0375
PSHH 0328
LSLL 0142
LG 0141
3/4"-CRU-011006013-103CS2P-H
011-SP-0190
21 20
POWER UNIT 011-XFR-41-01 NOTE 22
TRJR
POWER UNIT
2oo3
HH
ZC
PI
0379
0373 LL
HH
LDI
LI
0090
PY
0113 LL
NOTE 7 LDT GWR
0089
0090
0373
LL
D
3/4"
NOTE 7 LDT GWR
OIL
NOTE 7 LT GWR
0113
NOTE 7 PT 0373 A
NOTE 7 PT 0373 B
NOTE 7
2"
2"
PAH
INST. PIPING
TZV 0091
0355
3/4"
PAHH
LALL
0329
0145
+
TI 0376
PSHH 0329
N11B
4"
N13
4"
N14
N16
2" N12A
2" N12B
2" N12C
LSLL 0145
POWER UNIT 011-XFR-41-02 NOTE 22
18" N2
VENDOR
3/4"
MIN.
TRJR VENDOR
ID
2"
N15A PIPING INST.
NOTE 13
IA
6 6274TO 011-E-0032
DE
5
ZC
ZLS 0110 C
ATM
ZLS 0110 O
ZY 0110
ZHS 0110
0318
4
ES
ZHSR 0087
N10C 3"
RESET
ZC 0397 ES
ZC 0313
N1 18"
ZHXS 0087 L NOTE 2
1"x3/4"
MIN.
NOTE 24 N10D 3"
NOTE 23 N9B
2"
NOTE 23 N9E N6B N10E NOTE 24 N7E 3" 2" 4" CL300
N7D
2" CL300
2"-BRN-011007011-106CS2P-H
ZHA 0110
NOTE 24
ZHXS 0087
2"-BRN-011007011-106CS2P-H
S
ZYC 0110
MIN.
+
ZLO 0110
3"-CLD-011006309-103CS4P-P
ZYV 0110
7
DESALTER BRINE
ZLC 0110
NOTE 24 N7C 2" CL300
OPEN POSITIONER BY-PASS
6"-BRN-011006001-103CS4P-P
CLOSED
N7B N6A N3A N10B N10A 3" 2" 4" 6" 3" CL300
NOTE 6
NOTE 6
NOTE 11
3"-CLD-011006309-103CS4P-P
3"-BRN-011006302-103CS4P-H
NC
NOTE 24
2"
NOTE 23 N9D
2"
N15B
1"-CLD-011006310-103CS4P-P
N7A 2" CL300
UC
CRUDE 3897FROM 011-E-0009 A/B
NOTE 24
4"-CLD-011006309-103CS4P-P
3"
2"
NOTE 11
NOTE 6
18"-CRU-011006008-103CS1P-H
N8A
VENDOR TRJR
3"-CLD-011006309-103CS4P-P
D 1"
NOTE 6
2"-BRN-011007011-106CS2P-H
101CS1P 103CS4P
NOTE 21
NOTE 6
3"-CLD-011006309-103CS4P-P
8
NOTE 12 INST. PIPING
2"-BRN-011007011-106CS2P-H
9
0149
4"-CLD-011006309-103CS4P-P
NOTE 12
13
2"-BRN-011007011-106CS2P-H
GLASS
NOTE 23 N9A
NOTE 23 N9C
LG
3"-CLD-011006309-103CS4P-P
M1
6077
6" V
TI 0377
PAHH
LALL
0330
0148
PSHH 0330
LSLL 0148
V 3/4"
4"
103CS1P 101CH2F
NOTE 19 1"-CLD-011006307-103CH2S-P MIN.
16" N4
3/4" TRJR
2"x1"
1"-CLD-011006303-103CH2S-H
2"x1" 103CH2S 101CH2S
2"x1" 24" ID
M2
2"x1"
2"x1" N8B
N10F NOTE 24 3"
+
1"x3/4"
011-SC-0009
4902
3"-BRN-011006301-103CS4P-H
SC
NC
TYPE 7 NOTES 17,27
1"x3/4"
17
14 13
SC TYPE 7 NOTES 17,27
12 11
11
UC 3/4"-CLD-011006304-103CS1P-H
18
3"-LPS-011006301-101CS1P-H NOTE 21
2"
N7F 2" CL300
SC
1"
D
3"
NOTE 16
011-SC-0061
TRJR
19
011-SC-0015
6371
VENDOR
20
15
25
2"x1" NOTE 16
N3B 6"
24
16
2"-CLD-011006308-101CH2S-P
NOTE 16
2"
25
22
NOTE 16
2"
26
23
NOTE 16
2"
28
21
POWER UNIT 011-XFR-41-03 NOTE 22
TRJR
29
27
LG 0147
N5C
ZV 0110
3
FB LC NOTE 4
NOTE 3
FB LO NOTE 4
NOTE 5
NC 3/4"
3/4"
3/4"
10"
6" N11A
24"
10
0356
+
101CH2F 103CS1P FB LO NOTE 4
16"x8"
6061
4"
V
NOTE 28
VENDOR
011-D-0001
11
TZV 0092
3/4" 24"x10"
+
103CS1P 101CH2F
NOTE 5 29
PZV 0002
3/4"
30
0.2%
+
3/4"
29 6069
24"-LFL-011006302-101CH2F-N
8"T10" 15.09
NOTE 14
16
11
PAH
PSH 0356
N5B
17
14
+
NOTE 19
3/4"-CRU-011006014-103CS1P-P
15
011-SP-0015
3/4"X3/4" 0.40
LG 0144
3/4"-CRU-011006013-103CS2P-H
10" 4"
VENDOR
2"
+
NC
TZV 0082 +
3/4"X3/4" 0.40
16"x8"
1"
+
011-SP-0014
PSH 0355
101CH2F 103CS1P
PT 0373 C
NOTE 19
2" N5A
18
L
TZV 0081 +
1"x1/2"
10"
19
0089
L
1"
1/2"D1" 0.50
3/4"-CRU-011006012-103CS1P-P
23
LDC
H
PI 0373 D
+
32
0.2 %
24"-LFL-011006301-101CH2F-N 011-SP-0020
2"-BRN-011007011-106CS2P-H
EI 0043
ZC 0397
1/2"D1" 0.50
H
2198
3"-FLO-011006301-101CS1P-N 31
3/4"
103CS1P 103CS1P
EI 0042
CLOSED ZV-0111
ZC 0397
3/4"
V NOTE 4 LO FB
3/4" 24"x10"
16"-CRU-011006003-103CS1P-H
1"
FLO
D 3/4"
3/4"-CLD-011006311-103CH2S-H
ZC 0398
+
EI 0041
STOP PUMPS G-0001/G-0002
STOP G-0021-A/B 011-SP-0013
STOP PUMPS G-0001/G-0002
33
+
1"-CLD-011006307-103CH2S-P
+
VENDOR TRJR
3"-LPS-011006304-101CS1P-H
0379
1/2"-CLD-011006307-103CH2S-P
1/2"D1" 0.50
34
8"T10" 15.09 +
3/4"-CRU-011006011-103CS1P-H
ET 0043 L
TZV 0080
26
12
NOTE 28
PZV 0001
011-SP-0192
ET 0042 L
+
22
0313
NOTE 5
103CS2P 103CH2S
ET 0041 L
27
24
0319
V 3/4"
3"-CRU-011006006-103CS2P-H
1"-CLD-011006307-103CH2S-P
29 28
ZC
ZC
3"-CLD-011006309-103CS4P-P
II 0043 L
ZC
ZC
6288
3/4"-CRU-011006013-103CS2P-H
II 0042 L
ZC
STOP POWER UNIT
103CH2S 103CS2P
II 0041 L
ZC
1/2"-CLD-011006307-103CH2S-P
EI 0043 L
ZC
MIN.
MHSX D0001 L
EI 0042 L
CLOSE ZV-0111
29
STOP POWER UNIT
0.2%
30
OFF
EI 0041 L
ZC 0379
0.2%
HPT
MCC
TYP. 3
35
MIN.
10 9 8
18"-CRU-011006002-106CS2P-H
XL
STOP CLOSE CLOSE STOP STOP G-0024 ZV-0087 ZV-0085 G-0021 POWER UNIT
3/4"-LFL-011006303-101CH2F-N
31
STOP POWER UNIT
MHSR
32
3/4"-CRU-011006013-103CS2P-H
3/4"-CLD-011006311-103CH2S-H
ON
NOTE 15
103CS2P 103CH2S
33
MXA 0001 L
MD 0001
3/4"-OLW-011006307-101CS1P-N
011-LP-D-0001
36
18"-CRU-011006002-106CS2P-H
MIN.
35 34
MIN.
2" 18"-CRU-011006006-103CS2P-H
3/4"-CRU-011006007-103CS1P-P
0043
37
3/4"-CRU-011006010-103CS1P-P
0042
3/4"-CRU-011006013-103CS2P-H
MIN.
0041
NOTE 15
250 mm MIN.
II
103CS2P 101CS1P
II
38
OLW
103CS4P 101CS1P
II
TT 0274
3/4"-CLD-011006311-103CH2S-H
3/4"-OLW-011006307-101CS1P-N
37
TI 0274
103CS2P 106CS2P
NOTE 8 3/4" D
36
1"x3/4"
16"-CRU-011006001-106CS2P-H
LC
38
40
1"x3/4"
3500 mm
CRUDE 18"-CRU-011005002-106CS1P-H 6496 FROM 011-E-0009-A/B 18"x16"
INSULATION: H TRIM: CRU-011006601-103CS1P NOTE 7
106CS2P
6"-BRN-011006001-103CS4P-P
39
106CS1P
1"-OLW-011006307-101CS1P-N
011-SP-0191
40
41
1"-OLW-011006307-101CS1P-N
3/4"-CLD-011006305-103CS1P-P
TYPE 7 NOTES 17,27
4"x3"
7 6 5 4 3
6"-BRN-011006001-103CS4P-P
ZHSR 0110
IA DE
ES
RESET
ZHS 0087
ZY 0087
ZLS 0087 O
ZLS 0087 C
ATM ZV 0087 +
OLW
103CS4P 101CH2S
4"-CLD-011006302-101CH2S-P
MUD WASH WATER
FC TSO
DS011-TRJR-480015
FROM 011-G-0024-A/B
MIN.
6894
25 2826
2"x1" NOTE 26 103CH2S 101CH2S
2"-CLD-011006306-101CH2S-P OLW
DS011-TRJR-480013 2926
011-D-0001 HORIZONTAL 25000.0 3658.0 13.50 145.00 16.00 178.00
NOTE 10
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
GENERAL NOTES
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER NOTES 4 POTABLE WATER 1, 9, 20, 29 DELETED 2- LOCAL EMERGENCY SWITCH BEHIND FIREWALL OR IN SAFE LOCATION. 5 DEMI WATER 3- MECHANICAL LINK. 6 N.A. 4- GATE VALVE SHAL BE INSTALLED WITH STEM IN OR BELOW THE HORIZONTAL POSITION. 7 N.A. 5- MAKE CONNECTION ON TOP OF LINE. 6- MUD WASH INTERNAL HEADERS. SIX (6) HEADERS WITH SPRAY NOZZLES. EACH HEADER IS DESIGNED WITH TWO (2) SUBHEADER OF 1-1/2" SCH. XXS. PIPE, 4100 mm 8 N.A. LENGHT. TOTAL NO SPRAY NOZZLES: 120. 9 HP STEAM 7- SUPPLY BY DESALTER PACKAGE VENDOR AS LOOSE ITEMS. 10 MP STEAM 8- PROCEDURE FOR TURNING SPACER TO BE DEVELOPED TO FORBID THE SIMULTANEOUS BYPASS OF THE TWO DESALTERS IN SERIE AND THUS TO AVOID OVER 11 LP STEAM PRESSURE IN G-0002 SUCTION PIPING. 10- OP. TEMP. ºC: 140 - 150. 12 HP CONDENSATE 11- EFFLUENT WATER OUTLET HEADER (TWO INDEPENDENT SUBHEADERS OF 4" SH 160 CS PIPE AND LENGHT 12200 mm. 13 MP CONDENSATE 12- INTERFACE DRAW-OFF HEADER (TWO INTERNAL SUBHEADERS EACH ONE WITH TWO ADDITIONAL SUBHEADERS 3" SH. XXS CS. PIPE 12200 mm LENGHT. 14 LP CONDENSATE 13- CRUDE INLET HEADER (TWO INTERNAL SUBHEADERS OF 10" SH. 80 PIPE). 14- CRUDE OUTLET TRAY. 15 BFW 15- CONTINUOUS VENT (WTHOUT POCKETS). 16 PLANT AIR 16- VALVES GATE AND BALL FOR SAMPLING SYSTEM ARE SUPPLIED BY DESALTER VENDOR AS LOOSE ITEMS. 17 INSTRUMENT AIR 17- FOR SAMPLING DETAIL REFER TO VENDOR PID Nº. SA-JER-DS011-DSAR-210033. THE SAMPLE COOLERS ARE SUPPLIED BY DESALTER VENDOR. 18- DELETED. 18 N.A.
06
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
05
06-OCT-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
ARV / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
25 2827
19- TZV ( INTERNAL IN POWERUNIT) AND DEPRESSURIZATION DRAIN LINES, TO OLW CLOSED SYSTEM. 21- MAXIMUM STEAM OUT TEMPERATURE NOT TO EXCEED 170 ºC, TO PROJECT PTFE INTERNAL FROM DAMAGE. 22- POWER UNIT: 100 KVA, SEE INSTRUMENT VENDOR DRAWING SA-JER-DS011-DSAR-480002. 23- 2 INCH TRYCOCK NOZZLE. 24- SAND BLOWDOWN NOZZLE. 25- BYPASS USED WHEN ONLY 2ND STAGE (011-D-0002) IS IN OPERATION, AND 1ST STAGE (011-D-0001) IS OUT SERVICE. 26- BLIND IS TURN AT OPEN POSITION DUE TO FRECUENCY OF SAMPLING MONITORING. 27- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS011-TRJR-480274. 28- SET PRESSURE OF PZV-0001/0002 HAVE BEEN READJUSTED BASED ON A DISTANCE FROM UPPER TL OF 011-D-0001 TO PZV. THIS DIFFERENCE OF ELEVATION SHOULD NOT BE HIGHER THAN 12.8 METER.
mm mm barg °C barg °C
MIN
18"-CRU-011005002-106CS1P-H
SIGNAL TO 011-HS-0007
DRUM TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
1"
1
MIN.
1"-OLW-011006306-101CS1P-N
101CS1P 103CH2S
ZLC 0087
DS011-TRJR-480013 3899
MIN
250mm MIN.
011-SC-0017 SC TYPE 7 NOTE 27
ZLO 0087
101CS1P 103CS4P
ZHXS 0110
1"-BRN-011006004-103CS4P-P
ZYC 0087
2"-BRN-011007011-106CS2P-H
+
S
3/4"-OLW-011006301-101CS1P-N
0110 L NOTE 2
ZHA 0087
ZYV 0087
CLOSED
MIN.
ES
OPEN
106CS1P 103CS1P
ZHXS
2
TO 011-D-0002
BY-PASS POSITIONER
1
CRUDE
4"-CLD-011006309-103CS4P-P
MIN.
250mm MIN.
FC TSO
2
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 011-075 011-080 011-077
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 DESALTER FIRST STAGE
Item Tags : 011-D-0001
ORIGINAL SIGNED IN PROJECT FILE
Syst./ S-Syst.:
Discipline: PRO
COMPANY Document N° Contractor/Vendor Document N°
SA-JER-DS011-TRJR-480011 2271-011-PID-0021-006
Electronic Filename SA-JER-DS011-TRJR-480011.pid REV:
06
Sheet: 1 of 1
SCALE: NONE Format:
A1
011-D-0002 DESALTER
TO LDV-00923957
TRIM: CRU-011007601-103CS1P NOTE 7 1"-OLW-011007305-101CS1P-N
MD 0002
1"-OLW-011007305-101CS1P-N
ZC 0380
MCC
TYP. 3
TT 0276
39
1"x3/4"
1"x3/4"
NOTE 25 LC
3/4"-OLW-011007305-101CS1P-N
3/4"-CRU-011007015-103CS1P-H HPT
103CS1P 103CH2S
STOP POWER UNIT
ZC
ZC
ZC
0390
0398
0314
0323
3/4"
FB
1"x3/4"
LI 0114 LL
PSHH
LSLL
LG
0357
0378
0344
0152
0151
NOTE 7 LDT GWR
0092
0093
OIL
LT
NOTE 7 GWR
0114
NOTE 7
PT
PT
PT
0450 A
0450 B
0450 C
6"
4"
N11B
4"
N13
VENDOR
4"
N14
N16
2"
2"
2"
2" N12A
2" N12B
2" N12C
NOTE 14
3/4"
INST. PIPING
LALL 0155
TZV 0094 +
PSH
TI
PSHH
LSLL
LG
0358
0379
0345
0155
0154
POWER UNIT 011-XFR-41-05 NOTE 22
011-D-0002
TRJR VENDOR
103CS1P 103CH2S
2"
XL
MHSR
0053 L
0052 L
0051 L
0053 L
0052 L
0051 L
D0002 L
EI 0053 L
EI 0052 L
EI 0051 L
II 0053 L
II 0052 L
II 0051 L
4
ET 0053 L
ET 0052 L
ET 0051 L
3
1
MHSX D0002 L
EI 0052
OPEN
CLOSED BY-PASS POSITIONER
ZLO 0088
ZLC 0088
ZHA 0088
ZYC 0088
S
IA DE
ZLS 0088 O
ZLS 0088 C
ZHS 0088
ZY 0088
ATM
CL300
NOTE 19
MIN.
NOTE 23
EI 0051
NOTE 23
NOTE 23
2"
24 23
MIN.
2"
2"
2"
2"
103CH2S 101CH2S
2"x1"
2"-CLD-011007313-101CH2S-P M2 ID
2"x1"
24"
18 17
2"x1" VENDOR
TRJR 1" D
2"x1"
3" N8B
011-SC-0016
0319 ES ES NOTE 2 ZHXS ZHXS ZHSR ZYV 0111 L 0111 0111 0111 POSITIONER BY-PASS CLOSED OPEN +
ZYC
ZHA
ZLC
ZLO
0111
0111
0111
0111
ATM ZY
ZHS
ZLS
ZLS
0111
0111
0111 C
0111 O
TYPE 7 NOTE 17 3"-LPS-011007301-101CS1P-H
3/4"-CLD-011007306-103CS1P-H
SC
NC 3/4"-CLD-011007314-103CS1P-P
4911
13
3"-BRN-011007301-103CS4P-H
12
011-SC-0010
11
TYPE 7 NOTES 17,27
10 9
3/4"-CLD-011007311-103CH2S-H 8
3/4"-CRU-011007010-103CS1P-P TI 0275
FC TSO
7
DESALTER BRINE TO 011-G-0024 A/B 3968
5 6498 CRUDE FROM PDV-0006 MUD WASH WATER FROM 011-G-00243963 A/B
3/4"-CRU-011007018-103CS1P-P
SC
101CS1P 103CS4P
MIN
103CS4P 101CH2S
4"-CLD-011007302-101CH2S-P
TYPE 7 NOTES 17, 27
DS011-TRJR-480015 2954
MIN 2"x1" NOTE 26 103CH2S 101CH2S 2"-CLD-011007308-101CH2S-P OLW
06
13-MAR-2013
AB
MJR / STG
AVS / HCR
JAL
05
06-OCT-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
ARV / STG
RDP / MAC
JAL
REV
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
1
AB: AS BUILT
2818
011-073 011-072 011-073 011-071
3
TO 011-G-0002-A/B
25
GENERAL NOTES
4
2
CRUDE
2817
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER NOTES 4 POTABLE WATER 1, 9, 18,20,29 DELETED. 5 DEMI WATER 2- LOCAL EMERGENCY SWITCH BEHIND FIREWALL OR IN SAFE LOCATION. 3- MECHANICAL LINK. 6 N.A. 4- GATE VALVE SHAL BE INSTALLED WITH STEM IN OR BELOW THE HORIZONTAL POSITION. 7 N.A. 5- MAKE CONNECTION ON TOP OF LINE. 8 N.A. 6- MUD WASH INTERNAL HEADERS. SIX (6) HEADERS WITH SPRAY NOZZLES. EACH HEADER IS DESIGNED WITH TWO (2) SUBHEADER OF 1-1/2" SCH. XXS. PIPE, 4100 mm LENGHT. TOTAL NO SPRAY NOZZLES: 120. 9 HP STEAM 7- SUPPLY BY DESALTER PACKAGE VENDOR AS LOOSE ITEMS. 10 MP STEAM 8- PROCEDURE FOR TURNING SPACER TO BE DEVELOPED TO FORBID THE SIMULTANEOUS BYPASS OF THE TWO DESALTERS IN SERIE AND THUS TO AVOID OVER 11 LP STEAM PRESSURE IN G-0002 SUCTION PIPING. 12 HP CONDENSATE 10- OP. TEMP. ºC: 140 - 150. 11- EFFLUENT WATER OUTLET HEADER (TWO INDEPENDENT SUBHEADERS OF 4" SH 160 CS PIPE AND LENGHT 12200 mm. 13 MP CONDENSATE 12- INTERFACE DRAW-OFF HEADER (TWO INTERNAL SUBHEADERS EACH ONE WITH TWO ADDITIONAL SUBHEADERS 3" SH. XXS CS. PIPE 12200 mm LENGHT. 14 LP CONDENSATE 13- CRUDE INLET HEADER (TWO INTERNAL SUBHEADERS OF 10" SH. 80 PIPE). 15 BFW 14- CRUDE OUTLET TRAY. 15- CONTINUOUS VENT (WTHOUT POCKETS). 16 PLANT AIR 16- VALVES GATE AND BALL FOR SAMPLING SYSTEM ARE SUPPLIED BY DESALTER VENDOR AS LOOSE ITEMS. 17 INSTRUMENT AIR 17- FOR SAMPLING DETAIL REFER TO VENDOR PID Nº. SA-JER-DS011-DSAR-210033. THE SAMPLE COOLERS ARE SUPPLIED BY DESALTER VENDOR. 18 N.A.
6
2"
2"-BRN-011007012-106CS2P-H
1"
14
11
NOTE 21
2"
15
NOTE 27
8"-BRN-011007001-106CS2P-H
3/4"-CRU-011007017-103CS2P-H
16
SC
UC
ZC
+
19
25
RESET
ZV 0111
21
6392
N7F 2"
DE
22
2"x1"
TRJR
2"x1"
25
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
26
18"-CRU-011006002-106CS2P-H
OLW
mm mm barg °C barg °C
103CS1P 101CH2F
20
NOTE 16
4"-CLD-011007309-103CS4P-P
011-D-0002 HORIZONTAL 25000.0 3658.0 12.00 145.00 16.00 NOTE 10 178.00
4"
1"-CLD-011007305-103CH2S-H
TRJR
NOTE 16
011-SC-0062
19- TZV ( INTERNAL IN POWERUNIT) AND DEPRESSURIZATION DRAIN LINES, TO CLD CLOSED SYSTEM. 21- MAXIMUM STEAM OUT TEMPERATURE NOT TO EXCEED 170 ºC, TO PROJECT PTFE INTERNAL FROM DAMAGE. 22- POWER UNIT: 100 KVA, SEE INSTRUMENT VENDOR DRAWING SA-JER-DS011-DSAR-480004. 23- 2 INCH TRYCOCK NOZZLE. 24- SAND BLOWDOWN NOZZLE. 25- BYPASS USED WHEN ONLY 1ST STAGE (011-D-0001) IS IN OPERATION, AND 2ND STAGE (011-D-0002) IS OUT SERVICE. 26- BLIND IS TURN AT OPEN POSITION DUE TO FRECUENCY OF SAMPLING MONITORING. 27- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS011-TRJR-480274. 28- SET PRESSURE OF PZV-0001/0002 HAVE BEEN READJUSTED BASED ON A DISTANCE FROM UPPER TL OF 011-D-0002 TO PZV. THIS DIFFERENCE OF ELEVATION SHOULD NOT BE HIGHER THAN 12.8 METER.
28 27
3/4"
NOTE 16
IA
MIN.
29
3/4"
103CS2P FC 106CS2P TSO
1"-OLW-011007302-101CS1P-N
DRUM TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
FB LC NOTE 4
3/4"
1"-CLD-011007312-103CH2S-P
NOTE 16
S
8"x6"
ZV 0088
MIN.
NOTE 23
0319
+
4"x3" EI 0053
0088
0088 L NOTE 2
2" CL300
OFF
VENDOR TRJR
2
V
16" N4
N3B N10F NOTE 24 6" 3" ZC
N10E NOTE 24 N7E N6B 3" 2" 4"
3/4"
3/4"
NOTE 16
MIN.
5
ZHXS
NOTE 23
250mm MIN.
6
ZHXS
N7D
NC
30
MIN.
XL
0397
16"x8"
NOTE 5
3/4"-CLD-011007311-103CH2S-H
250mm MIN.
XL
ES
0314
NOTE 24 N10D 3"
101CH2F 103CS1P
FB LO NOTE 4
NOTE 28
6362
4"
V
25
10" N5C
N9E
NOTE 11
3/4" 24"x10"
+
103CS1P 101CH2F
31
3/4"-CRU-011007005-103CS1P-H POWER UNIT 011-XFR-41-06 NOTE 22
103CS4P 106CS2P
IT
0157
N15B
3"-CLD-011007309-103CS4P-P
IT
0158
N9D
NOTE 6
6"-BRN-011007013-103CS4P-P
IT
0088
ES
ZC
2"
4"-CLD-011007309-103CS4P-P
7
ON
ZHSR
ZC
NOTE 12
2"-BRN-011007012-106CS2P-H
8
N1 18"
18"-CRU-011007019-103CS2P-H
MXA D0002 L
3"-CLD-011007309-103CS4P-P
011-LP-D-0002
NOTE 24 N7C N10C 2" 3"
2"-BRN-011007012-106CS2P-H
0051
10 9
NC
CL300
3"-CLD-011007309-103CS4P-P
0052
II
6"-BRN-011007013-103CS4P-P
0053
II
NOTE 24
RESET
4"-CLD-011007309-103CS4P-P
II
N10B 3"
3500 mm
3"-BRN-011007302-103CS4P-H
NOTE 24 N7B N6A N3A 2" 4" 6" CL300
0346
N9C
3"-CLD-011007309-103CS4P-P
2"
N10A 3"
0380
N9B
2"-BRN-011007012-106CS2P-H
N7A 2" CL300
0359
N9A
NOTE 6
3"-CLD-011007309-103CS4P-P
D
UC
12 11
1"
NOTE 24
2"-BRN-011007012-106CS2P-H
3"-LPS-011007303-101CS1P-H
NOTE 11
2"-BRN-011007012-106CS2P-H
6401
3"
3"-CLD-011007309-103CS4P-P
NOTE 21
N8A
VENDOR TRJR
1"-CLD-011007310-103CS4P-P
101CS1P 103CS4P 11
NOTE 6
1"x3/4"
NOTE 12
LG 0159 GLASS INST. PIPING NOTE 6
LG
VENDOR
INST. PIPING
NOTE 6
LSLL
3/4"
NOTE 13
16 15
PSHH
6" N11A
N15A
18 17
3/4"
32
NOTE 5 29
PZV 0004
VENDOR
19
M1 ID
TI
29 6361
0.2%
+
LO NOTE 3 FB NOTE 4
PSH
33
0.2 %
24"-LFL-011007301-101CH2F-N
8"T10" 15.09
3/4"
3/4"-CRU-011007020-103CS1P-P
20
24"
LALL 0158
+
NOTE 19
10" N5B
PAHH 0346
TZV 0095
6" V 18" N2
+
PAH 0359
101CS1P 103CH2S
10" N5A
NOTE 7
NOTE 19 1"x1/2"
22
NOTE 7
PAHH 0345
+
3/4"X3/4" 0.40
3/4"-OLW-011007301-101CS1P-N
23
POWER UNIT 011-XFR-41-04 NOTE 22
NOTE 7 LDT GWR
D
3/4"X3/4" 0.40
PAH 0358
3/4"
103CS2P 103CS1P
24
3/4"
3/4"
011-SP-0018
+
1"x3/4"
TI
103CH2S 103CS1P
0.2% PY
011-SP-0017
+
1"
TZV 0085
1"x3/4"
PSH
011-SP-0193
25
TRJR
LL
0450
26
21
HH
PI 0450
0380
34
24"-LFL-011007302-101CH2F-N
16"-CRU-011007012-103CS1P-H
LL
2oo3
L
1"
TZV 0084
1/2"-CLD-011007312-103CH2S-P
+
PI 0450 D
ZC 0380
2"-BRN-011007012-106CS2P-H
L
LDI 0093
ZC 0397
ZC
011-SP-0195
H
LDC 0092
ZC 0397
+
35
2199
011-SP-0021
16"x8"
STOP POWER UNIT
1/2"D1" 0.50
3/4"-CRU-011007015-103CS1P-H
TZV 0093
LALL 0152
ZC 0380
1/2"-CLD-011007312-103CH2S-P
PAHH 0344
H
MIN.
HH
+
PAH 0357
ZC 0398
+
V NOTE 4 LO FB
NOTE 28
POWER UNIT
1/2"D1" 0.50
3/4" 24"x10"
+
3/4"-CLD-011007311-103CH2S-H 1"-CLD-011007312-103CH2S-P
MIN.
27
3/4"X3/4" 0.40
ZC 0319
STOP G-0001/G-0002
3/4"-LFL-011007303-101CH2F-N
28
1"
CLOSE CRU STOP PUMPS
POWER UNIT
103CS1P
29
011-SP-0016
+
STOP G-0021-A/B
101CH2F
TZV 0083
3/4"-CRU-011007015-103CS1P-H
30
CLOSE ZV-0111
3/4"-CLD-011007311-103CH2S-H
31
PZV 0003 STOP
ZC 0380
+
D 3/4"
+
NOTE 5
LO
V
1/2"D1" 0.50
8"T10" 15.09
6387
STOP POWER UNIT
32
FLO
29
3/4"-CRU-011007015-103CS1P-H
33
ZC
0.2%
NOTE 4
36
3"-FLO-011007301-101CS1P-N
MIN.
STOP CLOSE CLOSE G-0021-A/B ZV-0088 ZV-0085
35
37
250 mm MIN.
OLW
NOTE 15
103CS1P 101CS1P
NOTE 15
39
CRUDE 6497 FROM PDV-0006 38 UPSTREAM
24"-CRU-011007002-103CS1P-H NO POCKETS
3"-CRU-011007002-103CS1P-H
MIN.
3/4"-OLW-011007305-101CS1P-N
103CS4P 101CS1P
36
34
24"x18"
3/4"-CRU-011007015-103CS1P-H
NOTE 15
16"-CRU-011007006-106CS2P-H NO POCKETS
D 3/4" D 3/4"
2"
1"x3/4"
18"-CRU-011007002-103CS1P-H
3/4"-OLW-011007305-101CS1P-N
011-SP-0194
37
13
40
NOTE 8
LC
38
14
TI 0276
MIN.
40
41
SIGNAL
103CS1P 106CS2P
41
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080 011-077
011-D-0002
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 DESALTER SECOND STAGE ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480012 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480012 2271-011-PID-0021-007
REV: 06
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
SIGNAL 3957FROM LDC-0092
40
40
39
39 6497
38
CRUDE TO 011-D-0002 OUTLET
16"-CRU-011007006-106CS2P-H 38
2"-BRN-011007011-106CS2P-H
37
37
NC
36
36
PDI 0201
L
34
16"-CRU-011007006-106CS2P-H
PDT 0201 NOTE 8 PDT 0006
30
3/4"
PDV 0006 +
16" 18"x16"
26
18"x16"
MIN.
16"
PIPING INST.
MIN
UC
3/4"
NOTE 1
1"
NC
LPT
8"-BRN-011007001-106CS2P-H
MIN.
18"-CRU-011006002-106CS2P-H
PI 0289
NOTE 4 3/4" 3/4"
INST. PIPING
3/4"
PI 0303
MIN.
PIPING INST.
6"-BRN-011007005-106CS2P-H
PI 0296
NOTE 4 3/4" 3/4"
PI 0302
INST. PIPING 3/4"
6"x3"
MIN. MIN.
NOTE 3 8"x6"
ZC 0319
011-G-0024-A 3/4"
M
3/4"
NOTES 7,10
WATER
1-1/2"
TO OLW
3/4"
17 16 15 14 13 12 11
011-G-0024-B 3/4"
10
3/4"
NOTES 7,10
M
3/4"
TO OLW DS011-TRJR-480250 10779
TYP. 3
MUD WASH WATER
DESALTING WATER
DEMULSIFIER
FROM 011-E-0032
FROM 011-X-0003
FROM 011-D-0001
TO 011-D-0001
DS011-TRJR-480107 2942
DS011-TRJR-480125 2938
DS011-TRJR-480011 3899
DS011-TRJR-480011 2926
2824
011-G-0024-A / B DESALTER RECIRCULATION PUMPS INSULATION: H
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES
ø=33.4mm ext. REMOVABLE ELBOW
FLOW
60º
5 DELETED. 1- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 2- DISMOUNTABLE PIPING FOR POSIBLE CLEAN-OUT BY STEAM INJECTION. 3- PROVIDE A STRAIGHT LENGTH OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 4- CHECK VALVE SHALL BE INSTALLED HORIZONTALLY.
DETAIL "A"
VIEW FROM X 2mm
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
106SC1P 106CS2P
MIN.
25
6- BYPASS SHALL BE ONLY USED WHEN THE 2ND STAGE (011-D-0002) DESALTER IS IN OPERATION, IN THIS CASE THE PUMP 011-G-0024A/B AND 011-D-0001 ARE OUT OF SERVICE. 7- SELF VENTING TYPE PUMP. 8- SUPPLY BY DESALTER PACKAGE VENDOR AS LOOSE ITEMS. 9- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM : SA-JER-DS011-TRJR-480274. 10- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM : SA-JER-DS011-TRJR-480250.
05
13-MAR-2013
AB
04
30-SEP-2011
03
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
2 1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / FBL
RDP / MAC
JAL
00
11-DEC-09
IFD
IFD: ISSUED FOR DESIGN
JGT / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS.
5
DS011-TRJR-480010 2925
OLW
2823
6
1ST STAGE DESALTER WATER TO 011-D-0001
2"-CLD-011007303-101CH2S-P 25
7
3
OLW
GENERAL NOTES
QUILL INJECTOR
106CS2P 101CH2S
MG 0024 B
8
4
250 mm MIN.
106CS2P 101CH2S
2"-CLD-011007304-101CH2S-P
2"-BRN-011007011-106CS2P-H
1"-CHP-011053003-106SC1P-N
6"-PRW-011042006-106CS2P-H
18"-CRU-011006002-106CS2P-H CRUDE
0319
TYP. 3
2 1
ZC 2"x1-1/2"
250 mm MIN.
MG 0024 A
2"-BRN-011007012-106CS2P-H
NOTE 2
MCC
106CS2P 101CS1P
0319 2"x1-1/2"
CRUDE TO 011-D-0002
m³/h barg bar barg °C kg/m³
3/4"-OLW-011007304-101CS1P-N
MIN.
ZC
MIN.
MCC
9
WATER
NOTE 2 3/4"-OLW-011007303-101CS1P-N
5
19
1-1/2"-BRN-011007007-106CS2P-P
8"-BRN-011007001-106CS2P-H
011-G-0024-A / B CENTRIFUGAL 88.0 17.50 5.29 50.00 140.00 926.0
20
6"x3"
NOTE 3 8"x6"
3968FROM 011-D-0002
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
23
3/4"
3/4"
1"
24
6"x3"
18
MIN.
MUD WASH WATER 3963 TO 011-D-0002
3"
25
22
DS011-TRJR-480250 10778
6498
3/4" D
PIPING INST.
1-1/2"-BRN-011007006-106CS2P-P
3
6"x3"
LPT
7
4
1/2"
3/4" D
NOTE 1
D FI 0147
250mm MIN.
106CS2P 101CH2S
1-1/2"
DESALTER BRINE
26
STOP PUMP
3/4"
8
6
27
3" 6"x3"
LL
14
9
28
+
21
25
10
1/2"
D
4904
11
1/2"
3/4"
2"-CLD-011007301-101CH2S-P
12
1/2"
2"x3/4"
16
13
1/2"
NC
UC
15
1/2"
FT 0142 B
3/4"
17
1/2"
29
6"x3"
106CS2P 106SC1P
19 18
1/2"
3/4"-BRN-011007009-106CS2P-H TYPE 7 NOTE 9 SC 011-SC-0018 LDV DV 0092
FI 0142 B
MIN.
20
INST. PIPING
8"-BRN-011007004-106CS2P-H
FC
3/4"-CRU-011007004-106CS2P-P MIN 3/4"
21
30
6"-BRN-011007002-106CS2P-H
18"x16"
22
31
INST.
DETAIL "A"
24 23
PIPING
0142 A
18"x16"
FO NOTE 8
25
L
FT
INST. 3/4" PIPING
3/4" 3/4"
32
106CS2P 101CS1P
3/4"
3/4"
FI 0142 A
1-1/2"-BRN-011007007-106CS2P-P
3/4"
INST. PIPING
D 3/4"
MIN.
27
3/4"
INST. PIPING
33
MIN
INST. PIPING
28
PDC 0006
6"-CRU-011006002-106CS2P-H
29
FI 0177
1/2"
MIN.
31
NOTE 6
8"-BRN-011007004-106CS2P-H
32
FT 0177
6"-BRN-011007008-106CS2P-H
NOTE 8
33
1-1/2"-BRN-011007006-106CS2P-P
34
35
1/2"
6"-BRN-011007002-106CS2P-H
35
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080
011-G-0024-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 DESALTER RECIRCULATION PUMPS ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480013 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480013 2271-011-PID-0021-007
REV: 05
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
FC 37
0061 A
37
L
FV 0061
36
36
+
8"
10"x8"
10"-CRU-011008002-103CS1P-H
FO NOTE 10
34
35
10"x8"
MIN.
35
34
3/4" 33
31
MIN.
32
33
3/4" D
3/4"-CRU-011008021-103CS1P-P 2"x3/4"
32
PI 0010
103CS1P 101CH2S
250mm MIN.
30
2"-CLD-011008309-101CH2S-P
29
25
28
0061 A 1/2"
10 ø MIN. 24"-CRU-011007002-103CS1P-H
24"x20"
21 20
PIPING
24"x20"
INST.
19
1/2"
16"-CRU-011008013-103CS1P-H
0446
2"
CRUDE TO 011-E-0010-A/B
26 3978
25
TT
22
27
16"-CRU-011008001-103CS1P-H
24 23
INST. PIPING
H
TI 0446
25
29 28
3/4" 26
30
INST. PIPING
6988
1/2"
L
PT 0010
FT
27
31
1/2"
24
PIPING INST.
23
FT 0061 B
STOP PUMPS FI 0061 B
22
ZC 0397
21
LL
20 19
PI 0325
2"-CRU-011008012-103CS1P-P
18
101CS1P 103CS1P
15
2"-FLO-011008302-101CS1P-N
2200
MIN.
2206
FLO
2"
MIN.
FLO
16
2"-FLO-011008301-101CS1P-N
UC
3/4" D
LPT
MIN.
17
NOTE 3
17
MIN.
101CS1P 103CS1P
MIN.
2"-CRU-011008011-103CS1P-P
3/4"
MIN.
3/4"
18
2"
D
UC
LPT
16
NOTE 3
MIN.
15
MIN.
14
14
NOTE 2
13
13
8
PDT 0122 3/4"
3/4"
7
011-G-0002-A
INST. PIPING NOTE 1 20"x16"
NOTES 8,9 16"
HS
MIN.
3/4"
5
3/4"
1
3/4"
CRUDE FROM 011-D-0002 DS011-TRJR-480012 2954
3/4"
0009
12" 3/4"
9
PI
M
2"
8 7 6 5 4
2"-CRU-011008009-103CS1P-P MIN.
MCC
PY
MIN. NOTE 4
ZC 0397 ZC 0370
0%-50% MG 0002 A
SIGNAL
16"x12"
INST.
16"
2"-CRU-011008008-103CS1P-P
SPLIT RANGE 0007
NOTES 8,9 NOTE 1 20"x16"
PIPING
MIN
TYP. 3
50%-100%
3/4"
SIGNAL
SIGNAL
ZC 0322
103CS1P 101CH2S
SIGNAL TO FY-0006
FROM 011-PY-0373
TO 011-HS-0009B
25
DS011-TRJR-480002
DS011-TRJR-480019
DS011-TRJR-480011
DS011-TRJR-480019
2805
3633
3972
6894
7672
3
NOTE 4
TYP. 3
MCC
ZC 0397 ZC 0370
MG OLW
0002 B
011-G-0002-A / B DESALTED CRUDE PUMPS
2"-CLD-011008303-101CH2S-P
TO PV-0007
3/4"-OLW-011008301-101CS1P-N
103CS1P 101CS1P
2
3/4"
011-G-0002-B
INST. PIPING
2"
PC 0007
NOTE 7
0008
16"x12"
MIN.
24"-CRU-011007002-103CS1P-H
3
PI
M
4
2"
3/4"
12"
MIN
0007
INST.
10
MIN.
6
PIPING
PDT 0127
11
V
103CS1P 101CH2S
ZC 0322
3/4"-OLW-011008302-101CS1P-N
1
OLW
2"-CLD-011008304-101CH2S-P 25
INSULATION: H
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
RDP / MAC
JAL
00
11-DEC-09
IFD
IFD: ISSUED FOR DESIGN
NPS / FCB
RDP / MAC
JAL
2812
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
m³/h barg bar barg °C kg/m³
011-G-0002-A / B CENTRIFUGAL 1635.0 33.90 21.59 42.70 145.00 800.0
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
5, DELETED. 1- PROVIDE A STRAIGTH LENGTH OF PIPE AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 2- CHECK VALVE SHALL BE INSTALLED HORIZONTALY. 3- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 4- DISMOUNTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION. 6- LOCATED CLOSER TO DESALTER OUTLET. 7- TIE-IN ANTI-FOULING AGENT. 8- SELF VENTING TYPE PUMP. 9- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JER-DS011-TRJR-480245. 10- PROVIDE WITH MECHANICAL TRAVEL STOP AT 110% NORMAL CV. 11- DELETED.
2
103CS1P 101CS1P
9
V
3/4"
250 mm MIN.
0007
3/4"
H
2"-CRU-011008009-103CS1P-P
0007
0122
PDI 0127
16"-CRU-011008013-103CS1P-H
3/4"
PI
250 mm MIN.
10
PT
MIN.
12
MIN.
MIN.
NOTE 6
H
PDI
20"-CRU-011008012-103CS1P-H
INST.
2"-CRU-011008008-103CS1P-P
PIPING 11
20"-CRU-011008011-103CS1P-H
12
16"-CRU-011008001-103CS1P-H
NOTE 2
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 011-075 011-080 011-077
Item Tags : 011-G-0002-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 DESALTED CRUDE PUMPS ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480015 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480015 2271-011-PID-0021-008
REV: 05
Sheet: 2 of 3
SCALE: NONE Format:
A1
41
41
011-E-0010-A / B DESALTED CRUDE / HVGO EXCHANGERS
40
40
INSULATION SHELL/TUBE: H / H TRIM: CRU-011008601-106CS1P / HFO-011008601-106CS1P
39
39
14"-CRU-011008015-103CS1P-H
38
38
MIN. 37
37
2"-CRU-011008003-103CS1P-P
35
3/4"
34
2"
LPT
2"-FLO-011008303-101CS1P-N
103CS1P 101CS1P
36
D
36
FLO 2209
35 34
V
33
33
MIN.
HPT
29 28 27
TI
TT
2"
0243
0243
CL600
31
2"-CRU-011008020-103CS1P-P MIN.
30
103CS1P 101CH2S
2"-HFO-011013002-103CS1P-S 3/4" D
2"-CLD-011008308-101CH2S-P
CRUDE 3978FROM 011-G-0002 A/B
FLO
29
2208
28
V
2"
25
26
2"-FLO-011008304-101CS1P-N
14"-CRU-011008015-103CS1P-H
30
2"
103CS1P 101CS1P
31
32
16"-CRU-011008003-103CS1P-H
32
HPT
6066
LPT
20"x16" 25
CL600
20"
12"
B2
24
2"
A3
2"-HFO-011008017-103CS1P-S
011-E-0010-A 23
MIN.
NOTE 1
B3
A2
TI 0035
26 25 24
TT 0035
23
2" 10ø MIN. CL600
103CS1P 101CH2S
22
27
22
16"x14"
20 19 18 17
20" CL600 TI 0208
UC
2"
TW
18
A4
011-E-0010-B
3/4" TT
V
NOTE 1
LPT
20"
CL600
MIN.
MIN. 3/4" V
MIN.
14
17 16
20"x16"
2"CL600
16"-CRU-011008001-103CS1P-H
B4 12"
A1
0208
19
0279
CL600 B1
21
16"-CRU-011008003-103CS1P-H CRUDE TO 011-E-0011-A/B /0012-A/B3979 20
CL300
0278
16 15
12"
2"
TW
2"-CRU-011008018-103CS1P-P
MIN.
14"-CRU-011008015-103CS1P-H
21
15
LPT
14
2"-HFO-011008003-103CS1P-S UC
13
13
2"-HFO-011008019-103CS1P-P
MIN.
MIN.
12
2"
2" D
D
MIN.
2"-CRU-011008010-103CS1P-P
11
11
MIN.
12
10
10
103CS1P 101CH2S
103CS1P 101CH2S
8
250mm MIN.
2"-CLD-011008305-101CH2S-P
7 6
2"-CLD-011008306-101CH2S-P
25
25
2605
2606
9
250mm MIN.
2"-CLD-011008305-101CH2S-P
9
8 7 6
5
5
12"-HFO-011008016-103CS1P-S 4
10ø MIN.
3
2
2" CL600 12"-HFO-011008001-103CS1P-S
TT 0034
3
1
HVGO
HVGO
TO 011-E-0030-A/B
FROM 011-E-0015-A/B
DS011-TRJR-480100 2956
DS011-TRJR-480024 2957
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1- H.V.@ 150ºC SHELL AND TUBE SIDE. 2- DELETED.
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-E-0010-A / B AES 14.60 33.20 207.00 145.00 160.00 156.40 33.10 43.00 235.00 210.00 1365.0 7.65
NOTE 1
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
12"-HFO-011013002-103CS1P-S
TI 0034
2
4
LC
1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
DFI / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MMG / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 DESALTED CRUDE-HVGO EXCHANGERS
011-074 011-076 011-075 011-080 011-077
Item Tags :
011-E-0010 A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480016 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480016 2271-011-PID-0021-008
REV: 05
Sheet: 3 of 3
SCALE: NONE Format:
A1
41
011-E-0011-A / B DESALTED CRUDE/LAGO EXCHANGERS
40
011-E-0012-A / B DESALTED CRUDE/HAGO EXCHANGERS
INSULATION (SHELL / TUBE) : H / H TRIM: CRU-011009601-106CS1P / DIE-011009601-103CS1P
39
41 40
INSULATION (SHELL / TUBE) : H / H TRIM: CRU-011009602-106CS1P / HFO-011009601-103CS1P
39
12"-CRU-011009001-103CS1P-H 38
38
SP
37
FZC 0111
36
35
14"x12" 14"
34
35
8"x6" 8"
B2
34
A3
33
B3
A2 32
32
011-E-0011-A NOTE 5
31
FZY 0111
CL300
FC
2"
TW 0280
0111 A
CL300 8" 2"
TT
0042
0042
2"CL600
0281
CL600
TT
B1
28
TW
TI
A4
0284
FT 0110
LPT
TI 0044
23
2"-CRU-011009004-103CS1P-P 22
MIN.
MIN.
16
6"
14" CL300
103CS1P 101CH2S
0282
TI 0211
8" CL300
2"
TW
2"-CLD-011009305-101CH2S-P
2"
CL600 B1
0109
2"-CLD-011009308-101CH2S-P
0215
LPT
10
103CL2P 101CH2S 2"-CLD-011009307-101CH2S-P
12"x8"
5
12"x8"
8"
TI 0041
TT 0041
MIN.
MIN. 3/4"-CRU-011009003-103CS1P-P
3
3/4"
6"-DIE-011023006-103CS2P-H
6"-DIE-011009001-103CS1P-H
103CS1P 101CH2S
250mm MIN.
1
MIN.
D 2"x3/4"
2
9
+
6" FC
7
3/4"
5
5654
TT 0046 103CS1P 101CH2S 2"-CLD-011009306-101CH2S-P TI 0046 25 5653
4
6"
2"
NC
HAGO FROM 011-G-0013
MIN. 3/4"-HFO-011009003-103CL2P-P
DS011-TRJR-480057 2959
3/4" D
2"x3/4"
103CL2P 101CH2S
2"-CLD-011009307-101CH2S-P 2"-CLD-011009303-101CH2S-P LAGO
LAGO
HAGO
TO 011-E-0006
FROM 011-G-0011
TO 011-E-0009
DS011-TRJR-480007 2852
DS011-TRJR-480055 2958
DS011-TRJR-480010 2910
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 3,4- DELETED. 1- CONTROL LOGIC TO BE CONFIGURED TO PREVENT SIMULTANEOUSLY CLOSURE OF FV-0109/0110 IN CASE ONE FLOW SENSOR MALFUNCTION. 2- FLOW BALANCE THROUGH 2 TRAINS IS ACHIEVED IN AUTO MODE WITH MAX VALVE POSITION REGULATOR (TO ENSURE MAXIMUM VALVE OPENING CONTINUOUSLY). 5- H.V @ 150ºC (SHELL AND TUBE SIDE). EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-E-0011-A / B AES 13.30 30.60 233.60 156.40 171.00 170.10 33.10 43.00 265.00 200.00 505.4 NOTE 5 4.68
011-E-0012-A / B AES 13.20 30.10 295.30 151.40 170.00 176.50 33.10 43.00 325.00 205.00 665.2 NOTE 5 8.60
NOTE 5
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
8
6"-HFO-011009002-103CL2P-H
6
25
2"
TV 0031
D
MIN.
NC 4
TI 0350
2"-CRU-011009005-103CS1P-P
2"
250 mm MIN.
6
12
MIN.
12"-CRU-011008003-103CS1P-H
FO NOTES 1,2
14
11
10ø MIN.
MIN.
7
15
2"
LPT 10" 12"x10"
16
6074
6"-HFO-011009001-103CL2P-H
12"x10"
17
13
8"x6"
2"-HFO-011009004-103CL2P-P
+
8
18
25
D
FV 0109
1/2"
19
8"
MIN.
1/2"
0215
2"x3/4"
103CL2P 101CH2S
B4
250 mm MIN.
9
TI
MIN.
INST. PIPING
TT
2"-HFO-011009005-103CL2P-P
A4
MIN. 2"
D
NOTE 5
14" 14"x12"
3/4"
011-E-0012-B
TW 0283
A1
FT
10
MIN.
NC
12 11
20
2"x3/4"
4923
FC 0111 B
13
TT
B3
A2
5652
5651
25
21
8" A3
25
25
14
22
0211
2"-CLD-011009301-101CH2S-P
15
23
NOTE 5
2"-CLD-011009304-101CH2S-P
103CS1P 101CH2S
250mm MIN.
17
103CS1P 101CH2S
FO
2"
3/4" D
250 mm MIN.
MIN.
18
3/4"-CRU-011009002-103CS1P-P
D 2"x3/4"
8"x6"
B2
D
250 mm MIN.
3/4"
19
011-E-0012-A 14"x12" 14"
MIN.
24
PDV 0110
6"
2"
NC MIN.
2"CL600
MIN.
MIN.
16"x12" 16"-CRU-011008003-103CS1P-H CRUDE 3979FROM 011-E-0010 20 16"x12" 21
25
INST. PIPING +
3/4"-DIE-011009002-103CS1P-P
LPT
12"x10" 10" 12"x10"
TT 0044
PDC 0110
6"-HFO-011024006-103CL2P-H
MIN.
FO NOTES 1,2
PDT 0110
16"x12"
MIN.
12" 24
10ø MIN.
NOTE 5
MIN.
25
8"x6"
14"x12"
+
250mm MIN.
FV 0110
CRUDE 26 TO 011-E-00133980
16"-CRU-011009001-103CS1P-H
011-E-0011-B
MIN.
1/2"
27
D
2" CL600
8"
28
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION
25 4925
FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
3
FROM TC-0031
DS011-TRJR-480010
2
3644
1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
ARV / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS.
SIGNAL
MIN.
1/2"
A1 14"
16"x12"
29
250mm MIN.
INST. PIPING
26
3/4"
B4
30
MIN.
27
31
MIN.
29
14"
TI 0284
PIPING INST.
30
33
UC
MIN.
36
6"-DIE-011023006-103CS2P-H
2"-HFO-011009006-103CL2P-P
37
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE PREHEAT - LAGO AND HAGO
011-074 011-076 Item Tags :
011-075 011-080
011-E-0011-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
011-E-0012-A/B
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480017.pid
Discipline: PRO
SA-JER-DS011-TRJR-480017 2271-011-PID-0021-009
REV: 05
Sheet: 1 of 1
SCALE: NONE Format:
A1
41
41
011-E-0013 DESALTED CRUDE/LAGO PA EXCHANGER
40
40
INSULATION (SHELL/TUBE): H/H
39
TT 0048
39
TI 0048
38
38
CL600 2"
37
37
16"-CRU-011010001-103CS1P-H
16"-CRU-011010001-103CS1P-H
36
CRUDE 36 TO 011-E-0014-A/F3981
35
35
34
34
33 32
32
2" 20"x16"
31
18"x16"
31
TT 20"
30
A2
29
27
20"x16"
TI 0216
28 27
18"x16"
LPT
16"-CRU-011009001-103CS1P-H
26
3980 FROM 011-E-0011/011-E-0012
MIN.
MIN.
25
LPT
24
24
2"-DIE-011010005-103CS1P-P
23
TI 0047
2" D
2"
23
D 103CS1P 101CH2S
MIN.
MIN. 2"-CRU-011010008-103CS1P-P
22
2"
MIN.
MIN.
25
21
2"-CLD-011010305-101CH2S-P 19 18
16"-DIE-011010001-103CS1P-H
103CS1P 101CH2S
20
250mm MIN.
2"-CLD-011010304-101CH2S-P
25 6064
17 16
22
250mm MIN.
CRUDE
29
NOTE 3
18"
20"
30
011-E-0013
B2
A1 28
0216
18" B1
26
33
16"-DIE-011026003-103CS2P-H
21 20
25
19
6067
3/4"
18 17
16"x8" 16"x10"
8" 15
16"x8"
MIN. 14
2"x3/4"
+
10" 16"x10"
PDC
PDT
0111
0111
15 14
2"-DIE-011010006-103CS2P-P
13
13
3/4"
D
12
12
16" 103CS2P 101CH2S
11
9
10 ø MIN.
6 5
10" 12"x10" FC
6 5
2" 4
12"x10" 10" 12"x10"
3
1
D
2"x3/4"
2"-CLD-011010301-101CH2S-P
LAGO PA
SIGNAL FROM TT 0112
TO NAPHTHA SPLITTER REBOILER IN NHDT DS011-TRJR-480140 3102
3/4"
103CS2P 101CH2S
IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
NOTE 3
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DS011-TRJR-480064 2960
3982
2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEM SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
SHELL/TUBE SHELL/TUBE
1
FROM 011-G-0010
DS011-TRJR-480043
NOTES
2
LAGO PA
4929
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001).
011-E-0013 AES 8.70 28.90 247.20 167.50 229.40 179.50 33.10 43.00 275.00 215.00 455.0 8.20
3
25
GENERAL NOTES
1,2 DELETED. 3- H.V. @ 150ºC SHELL AND TUBE SIDE.
MIN.
16"-DIE-011010001-103CS1P-H
3/4"-DIE-011010003-103CS2P-P
250mm MIN.
MIN. 2
7
12"-DIE-011010002-103CS2P-H
16"-DIE-011026003-103CS2P-H
TT 0051
12"x10"
2"-CLD-011010301-101CH2S-P
TI 0051
4
8
+
MIN.
12"-DIE-011010004-103CS1P-H
9
MIN.
7
10
TV 0112
103CS1P 103CS2P
8
11
3/4"
20mm MIN.
TC 0112
10
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
FO
16
PDV 0111
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
DFI / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JCP / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080
011-E-0013
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE PREHEAT - LAGO PA. ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480018 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480018 2271-011-PID-0021-010
REV: 05
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
011-E-0014-A / B / C / D / E / F DESALTED CRUDE / VACUUM RESIDUE EXCHANGERS
40
3"J4" 42.14
INSULATION (SHELL/TUBE) : H / H
39
TZV 0017
CL300 3/4" 6"x4"
+
38
3981 FROM 011-E-0013
CRUDE
L
16"x12"
12"-CRU-011010006-103CS1P-H
35 34
10"-HFO-011014102-103CL2P-S
33 32
2"-HFO-011010111-103CL2P-P
10"
10"
2"
NOTE 1 TI 0354 14"x12"
CL600 14"
27
TI
011-E-0014-C 22
10"
B1 B6 10"
18
14"x12" 17
2" CL600
2"
TI
TI
0054
0353
011-E-0014-B
LPT
16
0056
011-E-0014-F
2" CL600 CL600
0006
14"
B5
10"
CL600
D 3/4"
CL600
2"
B2
B6
10"
+
011-E-0014-E
TW 0288
16"x10"
24"x16" MIN.
FLO CL300 NOTE 5
14" 2"
TI
TI
0053
0355
24"-CRU-011010005-101CH2S-H NOTE 2
NOTE 8
16"x8"
10" MIN. 3/4"
3/4"-CRU-011010007-103CS1P-P
D 2"x3/4"
LPT 10"-HFO-011010102-103CL2P-S
14
+
9
3" 6"x3"
6"x3"
6"-HFO-011010106-103CL2P-S
8
MIN.
FC
7
D
D
103CS1P 101CH2S
2"-CLD-011010308-101CH2S-P
TO 011-E-0031
TO SC-0023
DS011-TRJR-480104 3106
DS011-TRJR-480104 10780
103CS1P 101CH2S
103CL2P 101CH2S
25
25
25
5676
5677
5678
4"
6"x4"
4
3972
3
NC
250mm MIN.
103CS1P 101CH2S
SIGNAL FROM
3/4"-HFO-011010105-103CL2P-S
PC-0007
DS011-TRJR-480015
MIN.
7672
SIGNAL TO TV 0057
VAC. RESIDUE FROM 011-E-0018
2
DS011-TRJR-480027
DS011-TRJR-480027 3109
3983
1
3/4" D
2"x3/4"
103CL2P 101CH2S 2"-CLD-011010302-101CH2S-P
25
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
DFI / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
IRG / STG
RDP / MAC
JAL
4931
REV
4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DS011-TRJR-480015
6"x4"
CL600 2"
5
SIGNAL FROM PC-0007
MIN.
D
2"
250mm MIN.
2"
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED.
011-E-0014-A /B/C/D/E/F AES 15.50 27.60 283.00 177.30 206.40 200.00 33.10 43.00 NOTE 10 340.00 230.00 2817.0 16.00
6
MIN.
D
2"
GENERAL NOTES
IN/OUT IN/OUT
10
MIN.
MIN.
2"
MIN.
2"-CLD-011010309-101CH2S-P
25 5670
TT 0193
MIN.
MIN.
2"-CLD-011010310-101CH2S-P
25 5669
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
HV 0008
MIN.
MIN.
TI
H
10"-HFO-011010103-103CS1P-S
25 5667
SHELL/TUBE SHELL/TUBE
HC 0008
2"-HFO-011010109-103CL2P-S
6"-HFO-011010104-103CS1P-S
VAC. RESIDUE
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
11
3/4"
250mm MIN.
250mm MIN.
250mm MIN.
103CS1P 101CH2S 2"-CLD-011010313-101CH2S-P
1
103CL2P 101CH2S 2"-CLD-011010311-101CH2S-P
2
2"-CLD-011010306-101CH2S-P
3
2"-CRU-011010011-103CS1P-P
250mm MIN.
D
0193 103CS1P 101CH2S
14
4930
2"-CLD-011010308-101CH2S-P
D
15
12
2"-HFO-011010108-103CS1P-S
5
103CS1P 101CH2S
TI 0052
10ø MIN.
D
TT 0052
16
2"
2"
MIN.
2" MIN.
D
6
10"
17
25
HPT
MIN.
MIN.
MIN.
MIN.
2"
MIN.
18
13
2"-CRU-011010012-103CS1P-P
2"-HFO-011010110-103CL2P-S
MIN.
2"-HFO-011010107-103CS1P-S MIN.
7
CL600 2"
2" V
8
4
NOTE 1
10"
3/4"-HFO-011040014-103CS1P-S
9
LPT
10ø MIN.
10
LPT
MIN.
11
12"
MIN.
2"-CRU-011010009-103CS1P-P
12
NOTE 1
2"-CLD-011010303-101CH2S-P MIN.
12" 13
16"x12"
2"-CRU-011010010-103CS1P-P
16"x12"
103CS1P 101CH2S
19
250mm MIN.
LPT
10"-HFO-011010101-103CL2P-S
103CS1P 103CL2P
LPT
23
CRUDE TO 011-C-0001 3984 22
20
B5
250mm MIN.
MIN.
24
2" CL300
MIN. 15
25
TT 0057
NC CSC
14"x12"
LPT
8"
16"x8"
A5
CL600
14"
2" CL600
1/2"
FV 0006 16"x10" 10"
A2
14"x12"
INST. PIPING
2210
21
10" A6
A1
1/2"
CL300 10"
2"
TW 0287
14"x12"
B1
A5
14"x12"
LPT
MIN.
TI
TW 0286
A2
14"
CL600 14"
12"-CRU-011010003-103CS1P-H
MIN.
14"
2"
B2
A6
20
CL600
2"
TW 0285
14"x12" 14"
A1
B4
26
FLO
011-E-0014-D
CL300 10"
CL600 14"
12"-CRU-011010002-103CS1P-H
23
CL600
FT
011-E-0014-A
2" CL600
27
0057
2"-FLO-011010301-101CS1P-N
MIN.
24
TC
MIN. A4
A3
0055
28
10"
B3
B4
A3
30
FC 0006
CL600
14" A4
26 25
2" CL600
10"
B3
HS 0009 B
29
14"x12"
CL600
FY 0006
10"-HFO-011014102-103CL2P-S
TI 0352
31
NOTE 11
3/4" D
101CH2S 101CS1P
UC
28
19
FB LO NOTE 6
4"-CRU-011010013-103CS1P-H
MIN.
29
21
36
103CS1P 101CH2S
30
NOTE 7
MIN.
31
38
6972
37
MIN.
32
29
LO FB
NOTE 1
16"-CRU-011010001-103CS1P-H
33
6"-LFL-011010301-101CH2F-N
D
16"x12"
12"-CRU-011010006-103CS1P-H
39
0.2%
3/4"
2" CL600
35 34
NOTE 6
4"x3"
TT 0289
10 ø MIN.
TI 0289
H
V
CL600 NOTE 9
16"-CRU-011010006-103CS1P-H
37 36
40
+
TRIM: CRU-011010601-106CS1P / HFO-011010101-103CL2P
3, 4, DELETED. 1- SYMMETRICAL ARRANGEMENT. 2- TWO PHASE FLOW LINE. 5- FLASHING SERVICE. 6- BLOCK VALVE SHALL BE INSTALLED WITH STEM IN OR BELOW THE HORIZONTAL POSITION. 7- MAKE CONNECTION ON TOP OF PIPE. 8- MINIMUM LENGTH OF 5 PIPE DIAMETERS BETWEEN CONTROL VALVE OUTLET AND NEXT PIPE ELBOW. 9- SET PRESSURE READJUSTED BASED ON THE DISTANCE FROM UPPER TL OF E-0014 TO TZV. ELEVATION OF DIFFERENCE SHOULD NO BE HIGHER THAN 11.6 m. 10- H.V. @ 150° C SHELL AND TUBE SIDE. 11- HS-0009A AND HS-0009B WILL CHANGE THEIR POSITION SIMULTANEOUSLY TO CONTROL CRUDE INLET FLOW RATE TO THE UNIT THROUGH PV-0007 AND DESALTER PRESSURE THROUGH FV-0006. 12- DELETED. 13- DELETED.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE PREHEAT - VAC. RESID.
011-074 011-076 Item Tags :
011-075 011-080 011-077
011-E-0014-A/B/C/D/F
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480019.pid
Discipline: PRO
SA-JER-DS011-TRJR-480019 2271-011-PID-0021-010
REV:
05
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
011-C-0001 PREFLASH COLUMN ZC 0322
38
2oo3
CLOSED STRIPPING STEAM HH
H
TI
37
PI
LO FB
0011
NOTE 5
D
36 35 34
TT 0058
33
2"
0011 A
0011 B
6"
V
3/4"
PT 0011 C INST. PIPING
3/4"
DETAIL A NOTE 1
24"-NAP-011011001-101CH2S-P
26"
V1
H
PDI
PDI 0012 A
B2 30
3/4"
2"-NAP-011011001-101CH2S-P
0011 A
H
PDI 0011 B
H PDI 0011 C
DETAIL A NOTE 1
3/4" 14"x10" CL300 12"x8" NOTE 10
NOTE 5 V LO FB
PZV 0006 +
3/4" 14"x10"
V
NOTE 5 V LO FB
+
MH 24"
011-C-0001
28
PDI 0012 B
6" A3
NOTE 7
2" 2"
PT 0452
T1
PI 0452
19 18
16
6 P1
1
8"-MPS-011011302-103CS1P-H
8"-MPS-011011002-101CS1P-H
8"x6"
NOTE 13
P4 P5
CL150
6"
P6 A2A
30
3/4" D
2" L4B L2B 2"
D H
LC 0003
INST.
INST.
2" L3B 2" L4A
11
PIPING INST.
3/4"
MIN. PIPING
INSTR. PIPING
3/4" 10
5
V
2" L3A 2" L2A
4"
4"-MPS-011011301-103CS1P-H
S
11500 mm
4
2"
ZC 0340
2 1
BY-PASS
8"-MPS-011011302-103CS1P-H
3"-NAP-011098002-103CH2S-P
3
ZHA 0002
OPEN ZYC 0002
ZLO 0002
ZHS
ZY
ZLS
ZLS
0002
0002
0002 O
0002 C
WILD NAPHTHA
MP STEAM FROM MP HEADER
DS011-TRJR-480135 3112
DS011-TRJR-480142 3115
DS011-TRJR-480311 3985
6078
0322
NOTE 2
HH
ZHXS
29
ES
RESET ZHXS
ES
0002
ZC
ZHSR
0301
0002
LPT
+
TT 0060
ATM
6"-CRU-011011015-101CS1P-H 6" D
3/4"
OLW
6"-CLD-011011301-101CH2S-P 25
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES
CL 2mm
1" REMOVABLE ELBOW COLUMN TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
011-C-0001 mm mm barg °C barg °C
26710.0 7500.0 3.90 188.00 5.30 278.00
3" NOTE 3 NOTE 3
FLOW
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DETAIL "A" 101SC1P 101CH2P
NEUTRALIZING AGENT
FROM 011-X-0005
FROM 011-X-0004
TO 011-E-0004
DS011-TRJR-480022 3117
DS011-TRJR-480127 3124
DS011-TRJR-480126 3133
DS011-TRJR-480005 2847
05
13-MAR-2013
AB
PREFLASH OVERHEAD
4, 6,9,12 DELETED. 1- MAKE CONNECTION AFTER HIGH POINT. 2- LOCAL EMERGENCY SWITCH BEHIND FIREWALL OR AT SAFE LOCATION. 3- OP. PRESS. (barg) : 3.7 / 3.9 OP. TEMP. (ºC) :137 / 188. 5- BLOCK VALVE SHALL BE INSTALLED WITH STEM IN OR BELOW THE HORIZONTAL POSITION. 7- FOR NOZZLES DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING. 8- CORROSION MONITORING SYSTEM. 10- MECHANICAL LINK. 11- CONNECTION ON TOP OF PIPE. 13- CHECK VALVE AND ISOLATION VALVE ARE TO BE CLOSE TO THE COLUMN AND AT THE SAME PLANE OR ABOVE OF THE NOZZLE. 14- PZV-0005 A/B, PZV-0006 SIZE HAVE BEEN CALCULATED TAKING INTO ACCOUNT Cv RATED OF FV-0007 (Cv=102) AND ITS BY-PASS (Cv=100).
4 3
CRUDE TO 011-G-0004A/B
04
30-SEP-2011
03
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MRM / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MSS / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MRM / FCB
RDP/ MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MMG / FCB
RDP / MAC
JAL
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
3987
AB: AS BUILT
REV
GENERAL NOTES
60°
CORROSION INHIBITOR
2
4936
1"
6
NAPHTHA
MIN.
FC TSO 101CS1P 106CS1P
7
FROM-011-G-0003
24"-CRU-011011001-106CS1P-H MIN.
8
2"
B1 D1 6"
9
5
S
DE
NC
10
0060
ZYV 0002
IA 103CS1P 106CS1P 3/4"
12
TI
PUMP STOP
ZV 0002
13
11
0002 L
LL
ZC 0340
106CS1P 101CH2S SIGNAL TO FC-0014-B DS011-TRJR-480311
0370
0002 B
LT 0001
6"-OLW-011011303-101CS1P-N
FROM HDS UNITS
ZC
INST. PIPING
6"-CRU-011011006-106CS1P-P
SIGNAL TO FC-0014-A
14
NOTE 11
ZC
LI 0001
+
ZLC 0002
15
6076
LG
24"
24"-CRU-011011012-101CS1P-H
CLOSED
NC
2" 2"
16
3/4"-CRU-011011301-101CS1P-P
3/4"
INST.
2177
UC
NOTE 11
MAG
MH PIPING
17
CLOSED STEAM INJECTION
103CS1P 106CS1P 3/4"
MIN.
29
18
2066
3/4"-CRU-011011302-101CS1P-P
2" 2"
3/4"-LFL-011011302-101CH2F-N
3/4"-LFL-011011303-101CH2F-N INST.
M1
ID 24"
7
CRUDE FROM 011-G-004 A/B
HPT
INST. PIPING
8
19 3986
MAG
PIPING INST.
6
PT 0012 C
PIPING
2"
10
2" L1A
24
20
2"
PIPING INST.
2"
PY 0012
PT 0012 B
LG 0002 A
9
ZC 0323
21
PT 0012 A
0003
L
ZC 0314
22
LT
12
27
23
12"-CRU-011011005-101CS1P-H
INST. PIPING
13
ZC 0313
MIN.
14
28
2"-CHP-011054701-101SC1P-N
25
HPT
3/4"
15
ZC STOP PUMPS 0397
2" L1B
2"
2"-CHP-011054001-101SC1P-N
CLOSED CRUDE
PIPING INST.
2" 2"
12" A4
8"x6"
101CH2S 103CH2S
PIPING
2" 2"
33 32
0014
2" 2"
CL150 6" A2B
2"
34
26
PI 0012
TI 0059
MH 24" PIPING INST. 2" 2" PI
INST. PIPING 2"-NAP-011011003-103CH2S-P
31
250mm MIN. MIN.
17
A1
30"
30"x24"
TT 0059
35
29
101CS1P 101CH2F
20
M2
NO POCKET
103CS1P 101CS1P
21
24"-CRU-011010005-101CH2S-H
MIN.
3"-CRU-011010005-101CH2S-H
CRUDE 3984 FROM 011-E-0014
2"
AT 0036
3/4"
12"-NAP-011011001-101CH2S-P
12"-NAP-011011001-101CH2S-P
D
PDI 0012 C
PIPING INST.
24
NOTE 5
NO POCKET
P2
P3
36
CORROSION
101CH2S 101CH2F
6"-NAP-011012002-101CH2S-P
12
NOTE 8
6"-NAP-011012002-101CH2S-P
MH 24"
M3
37
101CH2S 101SC1P
101CH2S 101SC1P
101CS1P 101CH2F
PI 0013
25
INST. PIPING 2" 2"
AI 0036
V
101CH2S 101CH2F
6"-NAP-011012002-101CH2S-P
26
AI 0036
3/4"
101CH2S 101CH2F
2"x1"
27
38
CMS
3/4"
HH
PDI 0012
39
5292
+
2"-CHP-011054701-101SC1P-N
M4
19
2oo3
PZV 0005 B
3/4"
2"x1"
29
3/4" 14"x10"
FB LO
011-E-0004
2"-LFL-011003001-101CH2F-N
DS011-TRJR-480005
CL300 12"x8" NOTE 10
3/4" V
FB LO NOTE 5
3/4"
40
8"T10" 5.25 +
PZV 0005 A
CL300 12"x8" 011-SP-0022
3/4"
FB LC NOTE 5
14"
+
24"-NAP-011011001-101CH2S-P
26"x24"
31
22
PT
CL300
32
23
PT
V
NOTE 14
8"T10" 5.00
14"
8"T10" 5.00 +
3/4"
H
PY
0011
0058
2" 101CH2F 101CH2S
NOTE 11
NOTE 14
2"-CHP-011054001-101SC1P-N
39
14"
2039
TRIM: NAP-011011601-101CH2S / CRU-011011601-103CS1P / / CRU-011011602-101CS1P INSULATION: H
NOTE 14
24"-LFL-011011301-101CH2F-N
29
MIN.
40
0.2%
12"-NAP-011011001-101CH2S-P
41
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
1
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080
011-C-0001
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PREFLASH COLUMN ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480020.pid
Discipline: PRO
SA-JER-DS011-TRJR-480020 2271-011-PID-0021-011
REV:
05
Sheet: 1 of 3
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
FC 0008 A L
37
37
36
36
FV 0008
101CS1P 106CS1P
35 34
+
35
8" 12"x8"
12"x8"
34
MIN.
FO NOTE 9
33
12"-CRU-011011014-106CS1P-H
33
32
32
PI
31
0451 30 29
MIN. 3/4"-CRU-011011010-106CS1P-P
27
D
2"x3/4"
MIN.
28
3/4"
26 25 24
250 mm MIN.
106CS1P 101CH2S
24"x20"
101CS1P 106CS1P
101CS1P 106CS1P
1/2"
PIPING INST.
22
FT 0008 B
21
FI 0008 B
2"-CRU-011011003-106CS1P-P
ZC 0340
LL
STOP PUMPS
20 19
PIPING
3/4"
3
0016
TO OLW
3/4"
13 12
HYDROCARBONS
3/4"
TO OLW
3/4"
NOTE 1 20"x18"
011-G-0004-A
14
DS011-TRJR-480245 10782
16"x12"
MIN.
M
2"x3/4" 2"
3/4"
11 10 9 8
011-G-0004-B
7
NOTES 5, 8 6
2"-CRU-011011008-106CS1P-P
2"-CRU-011011009-106CS1P-P
MIN.
5
MIN.
NOTE 4 ZC 0301
ZC 0340
MCC
3/4"-OLW-011011301-101CS1P-N
0004 A
106CS1P 101CH2S
ZC 0301
NOTE 4
ZC 0340 ZC 0371
TYP. 6 MG
CRUDE 3987FROM 011-C-0001
3/4"
NOTES 5,8
2"
ZC 0371
2
M
2"x3/4"
PI
15
MCC
2"-CLD-011011302-101CH2S-P
106CS1P 101CS1P
4
3/4"
MIN.
5
MIN.
24"-CRU-011011001-106CS1P-H
6
HYDROCARBONS
DS011-TRJR-480245 10781
16"x12"
INST.
3/4"
PI 0175
20"x18"
MIN.
NOTE 1 8
3/4"
NOTE 2 PIPING
0361
3/4"
9
PI
3/4" NOTE 6
MIN.
3/4"
2303
PIPING
16
4 3
3/4"-OLW-011011302-101CS1P-N TOPPED CRUDE
TYP. 6
2
TO 011-E-0015A/B
106CS1P 101CH2S
MG 0004 B
250 mm MIN.
3/4" 10
INST.
FLO
MIN.
16"-CRU-011011004-106CS1P-H
0015
11
7
PI
17
2"-CRU-011011009-106CS1P-P
3/4"
PI 0148
INST.
MIN.
MIN. PIPING
LPT
NOTE 3
INST.
3/4"
NOTE 2
MIN.
PIPING
PI 0360
NC
UC
MIN.
12
PIPING
3/4" NOTE 6
MIN.
18
2"
D
20"-CRU-011011003-106CS1P-H
INST.
2302
LPT
NOTE 3
106CS1P 101CS1P
FLO
13
UC
2"-FLO-011011302-101CS1P-N
14
2" MIN.
3/4"
250 mm MIN.
15
D
2"-CRU-011011008-106CS1P-P
16
3/4"
INST.
CRUDE TO 011-C-0001
17
1
23
1/2"
12"-CRU-011011005-101CS1P-H
20"-CRU-011011002-106CS1P-H
3986
2"-CRU-011011002-106CS1P-P
2"-FLO-011011301-101CS1P-N
19 18
20"-CRU-011011001-106CS1P-H
24"x20"
20
26
24
16"-CRU-011011011-106CS1P-H
25
21
27
INST. PIPING
25
4937
22
28
16"-CRU-011011004-106CS1P-H
2"-CLD-011011304-101CH2S-P
23
30
PT 0451
INST. PIPING
1/2"
1/2"
L
29
FT 0008 A
3/4"
31
2"-CLD-011011303-101CH2S-P
OLW 25
25
2668
2665
DS011-TRJR-480024 3130
1
OLW
011-G-0004-A / B PREFLASH BOTTOM PUMPS
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JGT / STG
RDP / MAC
JAL
REV
DATE
INSULATION: N
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 7, DELETED 1- PROVIDE A STRAIGHT LENGTH OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 2- CHECK VALVE SHALL BE INSTALLED HORIZONTALY. 3- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 4- DISMONTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION. PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
m³/h barg bar barg °C kg/m³
011-G-0004-A / B CENTRIFUGAL 1522.0 34.70 29.29 43.00 188.00 800.0
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
5- HEAT SENSIBLE CABLE TO BE INSTALLED FOR FIRE DETECTION. 6- FLANGED GLOBE VALVE TYPE. 8- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JER-DS011-TRJR-480245. 9- PROVIDE WITH MECHANICAL TRAVEL STOP AT 110% NORMAL CV. 10- DELETED.
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080 011-077
011-G-0004-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PREFLASH BOTTOM PUMPS ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480021 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480021 2271-011-PID-0021-011
REV: 05
Sheet: 2 of 3
SCALE: NONE Format:
A1
41
41
40
40
39
39
CMS AI
38
AI
0032
38
0032 NOTE 7
37
37
FC 0009 A
36
36
CORROSION
AT 0032
35
INST. 34
PIPING
CL300 2"
0009 A FV 0009
PIPING
+
6"x4"
32
34
INST.
2"-NAP-011012020-103CH2S-P
33
35
FT
4"
1/2"
1/2"
6"x4"
33 32
CL300
FO CL300
31
3/4" D
PIPING
4"
30
6"x4"
NC
FT 0009 B
3/4"
MIN.
3/4"-NAP-011012007-101CH2S-P 2"x3/4"
28
1/2"
INST.
MIN.
6"x4"
29
1/2"
6"-NAP-011012002-101CH2S-P
31
D
2" 26 25
2"-CLD-011012301-101CH2S-P 24
250mm MIN.
27
30 29 28 27
FI
26
0009 B
L 25 24
6"-NAP-011012006-101CH2S-P
25 4940
23
23
22
22
21
4011 SIGNAL 011-LC-0004
FROM 011-D-0003
20 19
4" NOTE 9 CL300 6" CL300
6"x4"
7
3/4"
MIN. 8"x6"
NOTE 3
011-G-0003-B
6"-NAP-011012006-101CH2S-P PIPING
NOTE 9 3/4"
6"x4"
3/4"
MIN.
4"
CL300 6"
8"x6"
CL300
M
6
PI 0141
M
1-1/2"
13 12
NOTE 3
1-1/2" 3/4"
3/4"
14
4"-NAP-011012021-103CH2S-P
11
9
MIN.
MIN. 3/4" D 2"x3/4"
103CH2S 101CH2S
5
1-1/2"-NAP-011012009-101CH2S-P
1-1/2"-NAP-011012008-101CH2S-P
2"-CLD-011012306-101CH2S-N
MIN.
6"-NAP-011012002-101CH2S-P
1
OLW
NOTE 6
0341
MCC
3/4"
TYP. 3 3/4"-OLW-011012302-101CS1P-N MG 0003 A
2"
OLW 2"-CLD-011012302-101CH2S-P
MIN.
2"x1-1/2"
101CS1P 101CH2S
3/4"-OLW-011012301-101CS1P-N
ZC
TYP. 3
2"x1-1/2"
3
4942
2
FROM 011-G-0007 A/B DS011-TRJR-480140 3146
1
MG 0003 B
2" 2"-CLD-011012303-101CH2S-P
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
2666
2667
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / JLM
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MRM / JLM
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
011-G-0003-A / B PREFLASH REFLUX PUMPS GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 2, 8 DELETED. 1- NAPHTHA FILLING LINE. 3- PROVIDE A STRAIGTH OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 4- CHECK VALVE SHALL BE INSTALLED HORIZONTALY. 5- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 6- DISMONTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
4
25
0341
DS011-TRJR-480020 3117
m³/h barg bar barg °C kg/m³
5
25
NAPHTHA
011-G-0003-A / B CENTRIFUGAL 106.0 7.40 3.08 11.30 106.00 622.0
6
25
TO 011-C-0001
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
7
ZC NAPHTHA
MIN.
2
MCC
3/4"
101CS1P 101CH2S
NOTE 6
250 mm MIN.
3
8
MIN.
250 mm MIN.
4
10
3/4"-NAP-011012012-103CH2S-N
MIN.
3/4"
8
D
3/4" INST.
3/4"
UC
NOTE 4
4"-NAP-011021006-103CH2S-N
011-G-0003-A
INST. PIPING
9
PI 0020
15
3/4"
NOTE 1
PI 0139
0019
10
16
101CH2S 103CH2S
8"-NAP-011012005-101CH2S-P
3/4"
1-1/2"-NAP-011012009-101CH2S-P
PI
8"-NAP-011012001-101CH2S-P
11
INST.
12
UC
PIPING
13
3/4"
7- CORROSION MONITORING SYSTEM. 9- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JER-DS011-TRJR-480251.
18 17
MIN.
NOTE 4 6"-NAP-011012002-101CH2S-P
1-1/2"-NAP-011012008-101CH2S-P
14
1-1/2"
19
LPT
250mm MIN.
NOTE 5 16 15
4015 NAPHTA FROM 011-D-0003
4"-NAP-011012001-101CH2S-P
MIN.
INST.
17
20
LPT
PIPING
NOTE 5 1-1/2"
MIN.
18
MIN.
8"-NAP-011012001-101CH2S-P
21
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080
011-G-0003-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PREFLASH REFLUX PUMPS ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480022 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480022 2271-011-PID-0021-012
REV: 05
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
011-D-0003 PREFLASH REFLUX DRUM
40 39
NOTE 9
6"R8" 5.00 +
38
29 2040
011-SP-0023
NOTE 4 2" 101CH2F 101CH2S
34
NC
CL300 12"x6"
NOTE 2
V
3/4"
6"R8" 5.00
35 34
PZV 0007 +
14"x8"
12"-NAP-011012003-101CH2S-P 33
FB LO NOTE 3
CL300 12"x6"
V
0010
30
3/4" D
LC FB NOTE 3
29
LO FB NOTE 3
PC 0021
FT 0010
28 27
PT 0021
HPT
PI 0022
PIPING INSTR. MIN.
MIN.
3/4"-LFL-011012302-101CH2F-N
3/4" D
TO FC-0009
D
1/4"
NAPHTA TO 011-G-0003 A/B
LI 0006
8"-NAP-011012001-101CH2S-P
18 17 16 15
INST. PIPING
V
20"
2"
24
B2
P2
P1
011-D-0003 NOTE 6
L1B
2" INST. PIPING 2" 2"
LG 0005
23 22
2"
M1
21
24" ID
M2
24" ID
20
L1A 19
L2A
2"
LL
D 1/4"
2"
D 1/4" UC
2"
2"-NAP-011012019-101CH2S-P 3/4"
L3A S1
MIN.
V MIN.
ZC 0341 INSTR. PIPING NC
2" 2" 2"
INSTR. PIPING
MAG LDG
3/4" 3/4"-NAP-011012017-101CH2S-P
HPT
12 29
101CH2S 101CH2F
MIN. 3/4" D
LDT
1/4" D
0008
3/4"
2"
NOTE 4
2" 101CH2S 101CS1P
3/4"-LFL-011012303-101CH2F-N
LDT
LDI
0009
0009
D 1/4"
B3
ZV 0022
2"
NOTE 1
ZXHX
2" 2"
L4A
16
ES
PIPING INST.
L5A
17
D 1/4"
L6A
10 9
2"
L5B
2"
2" D1 2" 2"-AWS-011012006-101CH2S-P
B1 MIN.
8"
L4B L6B
1/4" D 2" INSTR. PIPING NC
150 mm
2" 2"
0007
NC
4944
18
INST. PIPING
2"
13
11
2"
L2B
MAG LT 0006
2"
MIN.
14
27
25
+
15
0022 L 14 LL
ZXHS
ZC 0374
ES
0022
RESET
CLOSED
OPEN
BY-PASS
ZC
ZHSR
ZLC
ZLO
ZHA
0374
0022
0022
0022
0022
13 12
ZV CLOSURE 11
ZYV 0022 +
FC TSO
S
ZLS 0022 C
IA DE
ZLS 0022 O
FI 0148
ZHS 0022
10 9
2"-OLW-011012305-101CS1P-N ATM OLW LDC 0008
MIN.
5
101CS1P 101CH2S 2"-CLD-011012304-101CH2S-P
OLW
25 2687
PREFLASH OVERHEAD FROM 011-E-0004
8"-NAP-011012001-101CH2S-P
PIPING 2" INST.
2"-AWS-011012001-101CH2S-P
3/4" D
3/4" 1-1/2"x3/4" NC 1-1/2"x3/4"
SC 3/4"
MIN.
1
FC CL300
D
MIN.
D
DS011-TRJR-480005 2848
TYPE 14 011-SC-0027 NOTE 7
2"
2"-CLD-011012307-101CH2S-P
0021
1"-CWS-011012301-101CS1P-N
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES
DRUM TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
mm mm barg °C barg °C
011-D-0003 HORIZONTAL 7000.0 2800.0 3.00 110.00 5.50 140.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
5, DELETED. 1- LOCAL EMERGENCY SWITCH BEHIND FIREWALL OR IN SAFE LOCATION. 2- MECHANICAL LINK. 3- BLOCK VALVE SHALL BE INSTALLED WITH THE STEM IN OR BELOW THE HORIZONTAL POSITION. 4- CONNECTION ON TOP OF THE PIPE. 6- FOR NOZZLES DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING. 7- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS011-TRJR-4800274 AND 480275. 8- LOCATED IN SELF STANDING RACK. 9- SET PRESSURE OF PZV-0007/08 HAVE BEEN READJUSTED BASED ON A DISTANCE FROM UPPER TL OF D-0003 TO PZV. THIS DIFFERENCE OF ELEVATION SHOULD NOT BE HIGHER THAN 5.6 mts.
FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
SIGNAL
2
TO PY 0021
TO 011-A-0002
DS011-TRJR-480113 3155
DS011-TRJR-480050
DS011-TRJR-480048 3160
4016
1
32
3/4" 32
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
AVS / MAC
JAL
SIGNAL TO 011-AY-0021A/B
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
RDP / MAC
JAL
DS011-TRJR-480126
00
11-DEC-09
IFD
IFD: ISSUED FOR DESIGN
JVM / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
AC 0021
1/2" CL150
1"x1/2"
05
13-MAR-2013
AB
04
30-SEP-2011
03
8257
3/4"
1"-CWR-011012301-101CS1P-N
UTILITIES IDENTIFICATION 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
4
8256
3859
DESCRIPTION
5
AB: AS BUILT
25
POS.
6
NAPTHA VAPOR
TO 011-D-0006
6892
GENERAL NOTES
7
3 SOUR WATER
PIPING INSTR.
NOTE 8 1/2" CL150 pH 1"x1/2" AT
3/4"-AWS-011012009-101CH2S-P UC 0320
8
2"-AWS-011012008-103CH2S-P
2"x3/4"
250mm MIN.
24"-NAP-011003001-101CH2S-P
3/4"-OLW-011012303-101CS1P-N
3/4"
SAMPLE LINE
2"x3/4" 2"-AWS-011012004-101CH2S-P
1/2"
1" 2"x1"
2"x1"
2"-AWS-011012007-103CH2S-P
250mm MIN.
2
MIN.
1/2"
INST. PIPING
+
2"-AWS-011012001-101CH2S-P
MIN.
3
L
LDV 0008
LPT
4
ZC 0374
INST. PIPING
6
FMC H
RETURN LINE
7
FT 0148
20"-NAP-011012004-101CH2S-P NO POCKET
3/4"-AWS-011012004-101CH2S-P
3/4"-AWS-011012003-101CH2S-P
8
3/4"-AWS-011012002-101CH2S-P
4015
PIPING
1/2"
26
L3B
2"
D 1/4"
LT 0004
L
PUMP STOP
20
H
LC 0004
1/2"
PIPING
2"
W1
2"
2"
INST. PIPING 21 4011 SIGNAL
12"
A1
2"
3" V
MIN.
22
MIN. 24"
NC
23
28
INST.
INST.
101CH2F 101CH2S
24
TYPE 13 011-SC-0040 SC NOTE 7
TI 0061
20"-NAP-011012004-101CH2S-P
3/4"-NAP-011012016-101CH2S-P
NOTE 4
29
3/4"-NAP-011012011-101CH2S-P 2"
2082
19
TT 0061
29
25
31
3/4" D
30
26
32
FI
3/4"
3/4" 31
36
+
2"
MIN.
NOTE 9
101CH2F 101CH2S
101CH2F 101CH2S
33 32
NOTE 4
3/4"
37
7600 mm
35
38
+
8"-NAP-011012001-101CH2S-P
36
39
PZV 0008
NOTE 3 3/4" V LO 14"x8" FB 14"-LFL-011012301-101CH2F-N
0.2%
37
40
TRIM: NAP-011012601-101CH2S / NAP-011012602-103CH2S / AWS-011012601-103CH2S INSULATION: P
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 011-075 011-080
Item Tags :011-D-0003
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PREFLASH REFLUX DRUM ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480023.pid
Discipline: PRO
SA-JER-DS011-TRJR-480023 2271-011-PID-0021-012
REV:
05
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
41
011-E-0015-A / B TOPPED CRUDE/HVGO EXCHANGERS
40
40
INSULATION (SHELL/TUBE): H/H TRIM: CRU-011013601-106CS1P / HFO-011013602-106CS1P
39
39
38
38
37
37
36
36
TI 0062
35
35
12"-CRU-011013001-106CS1P-H
34
34
TT 0062
33 32
33 32
2" 16"-CRU-011013002-106CS1P-H MIN.
31
MIN. 30
LO
TOPPED CRUDE 31 TO 011-E-0016-A/B 4031
16"-CRU-011013002-106CS1P-H
LO
10ø MIN.
30
2" 29
29
MIN.
2"-CRU-011013016-106CS1P-P
28
28
2"
D
MIN.
3/4"
106CS1P 101CH2S
25
20"
23
12"-HFO-011013001-103CL2P-S
20"x16"
24
12" B2
A3
22
B3
A2
21
011-E-0015-A 20
NOTE 4 12" CL300
20" CL600
19
TW 0063
18
TW
2" 2"
17
B1
0351
27 26 25
250 mm MIN.
26
D
2"-CLD-011013315-101CH2S-P
7789
101CS1P 106CS1P
FLO
27
2"-CRU-011013002-106CS1P-P
2"-FLO-011013309-101CS1P-N
24 23
ZHS 0124
ZHA 0124
BY-PASS
ZY 0124
ZYC 0124
POSITIONER
ZLS 0124 O
ZLO 0124
OPEN
ZLS 0124 C
ZLC 0124
CLOSED
25 7788
ZC 0421
22 21 20
NOTE 5 ZHSR RESET 0124
011-E-0015-B NOTE 4
19
SP
18
FC 0049
17
ZC
A4
0421
16
A1 15
16
B4
12"
20"
ZYV 0124 +
S
14
TI 0195
PB
FHSR
H
0049
ZC
15
0421
RESET
14
20"x16"
FT
IA
ATM ZV 0124 +
2" CL600
TI
2"-HFO-011013021-103CS1P-S
H
0068
5
103CS1P 101CH2S
2"
TT 0068
MIN.
2"-CRU-011013011-106CS1P-P
D 2"-CRU-011013013-106CS1P-P
106CS1P 101CH2S
2"-CLD-011013312-101CH2S-P
106CS1P 101CH2S
250 mm MIN.
1
MIN.
2
2"
250 mm MIN.
16"-CRU-011011004-106CS1P-H
D
MIN.
3
2"-CLD-011013314-101CH2S-P
2" CL600
12"-HFO-011013002-103CS1P-S
MIN.
2"-CLD-011013313-101CH2S-P 25
HH
2"
25
6357
7831
TT 0389
TI 0389
ZC 0421 CLOSE ZV-0124 CLOSE FV-0049
TOPPED CRUDE
HVGO
FROM 011-G-0004A/B
TO 011-E-0010A/B
DS011-TRJR-480021 3130
DS011-TRJR-480016 2957
D MIN.
8"x6"
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-E-0015-A / B AES 17.00 33.20 257.80 188.00 207.00 201.40 33.10 43.00 290.00 230.00 1284.0 8.84
NOTE 4
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
9
6"
6
8"x6"
5
MIN. 3/4"
3/4"-HFO-011013011-103CL2P-S
D
2"x3/4"
4 3
2" 103CL2P 101CH2S
103CL2P 2" 101CH2S
2 1
2"-CLD-011013302-101CH2S-P 25 4945
25
MVGO
9416
FROM 011-G-0016
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
10
7
NC
GENERAL NOTES
1, 2, 3,DELETED. 4- H.V. @ 150ºC (SHELL AND TUBE SIDE). 5- COMMON RESET SHALL BE CONFIGURATED IN SIL 3 VALVES. 6- DELETED.
3/4"
3/4"
DS011-TRJR-480099 3166
NOTES
4035 HVGO FROM 011-E-0016-A/B
12"-HFO-011013001-103CL2P-S
8
2"
D
6358
CL600 25
MIN. 250 mm
4
MIN.
12"x6"
MIN.
D
2"x3/4"
11
FC
MIN.
MIN.
6
2"
2"
2"-CLD-011013320-101CH2S-P
LPT
7
MIN.
MIN. 3/4"
10ø MIN.
250 mm MIN.
LO
LPT
FC TSO
MIN.
2"
MIN.
12"x6" 6"
2"-HFO-011013027-103CL2P-S
LO
MIN.
D
2"-HFO-011013028-103CL2P-S
8
3/4"
MIN.
TT 0234
FV 0049 +
10 9
12
250 mm MIN.
UC
INST. PIPING
MIN.
MIN.
1/2"
1/2"
MIN.
0234 11
ATM
TT 0195
2"-CRU-011013012-106CS1P-P
DE
MIN.
TI
S
+
6"-HFO-011038003-103CL2P-S
12
13
0049
FYV 0049
DE
13
06
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
05
06-OCT-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
SIGNAL FROM 011-LC-0048
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / FBL
RDP / MAC
JAL
DS011-TRJR-480081
00
11-DEC-09
IFD
IFD: ISSUED FOR DESIGN
VJS / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
4026
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
Item Tags :011-E-0015-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 TOPPED CRUDE PREHEAT - HVGO ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480024 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480024 2271-011-PID-0021-013
REV: 06
Sheet: 1 of 3
SCALE: NONE Format:
A1
41
011-E-0016-A / B TOPPED CRUDE/HVGO PA EXCHANGERS
40
INSULATION (SHELL/TUBE): H/H
41
MIN. 2"-CRU-011013003-106CS1P-P 2"-FLO-011013311-101CS1P-N
38
MIN.
LO
LO
3137
MIN.
35
3/4"
14"
A1
16"-CRU-011013002-106CS1P-H
14" LPT
D
33
12"
B1
011-E-0016-A
34
2"
2"-CRU-011013017-106CS1P-P
14"x12"
V
A2
106CS1P 101CH2S
B2
12"
HPT V
FLO 7759
30
3/4"
V MIN.
MIN.
MIN.
29
2"
28
31
2"-HFO-011015003-103CL2P-S
2"-FLO-011013302-101CS1P-N
2247
25
LPT
32
2"
2"-CLD-011013316-101CH2S-P
14"x12"
29
MIN.
28
TI
2"-CLD-011013304-101CH2S-P
12"-CRU-011013015-106CS1P-H MIN. 2"-CRU-011013004-106CS1P-P
16"x12"
18
FLO
106CS1P 101CS1P
2"-FLO-011013310-101CS1P-N
17
11
HVGO TO 011-E-0015-A/B
21
25
20
MIN.
7760
2"-HFO-011015003-103CL2P-S
19
2"
FLO
TT
TI
0292
0292
3/4"
V
V MIN.
18
2"
17
2" MIN.
MIN.
2" LO
16
2" 2"-HFO-011013026-103CL2P-S
LO
D
15 14
103CL2P 101CH2S
2" 12"-HFO-011015003-103CL2P-S
14"x12"
3/4"
14"
V
A2
011-E-0016-B A1
14" LPT
9
B2
106CS1P 101CH2S
12"
14"x12" 2"
7
TI 0067
6
MIN.
MIN.
2"
D
MIN.
2" 2"-CRU-011013006-106CS1P-P
2"-HFO-011013008-103CL2P-S
D
2"
2"-HFO-011013023-103CL2P-P
2"-CLD-011013318-101CH2S-P
12 11
V TT 0196
16"x12"
TI 0196
25
10
7761
NOTE 1 9
2" 8 ø MIN.
16"x14"
8
25 7762
MIN.
5
13
MIN.
2" D
LPT
MIN.
8
MIN.
2"-CRU-011013018-106CS1P-P
12"
B1
12"-HFO-011013001-103CL2P-S
4
22
2"
NOTE 3 4035
103CL2P 101CH2S
HPT
7763
250mm MIN.
12
HPT
2"-CLD-011013319-101CH2S-P
13
D
3/4"
MIN.
14
2" V
MIN.
2"-CRU-011013008-106CS1P-P
15
MIN.
12"-CRU-011013002-106CS1P-H
UC
23
18"x12"
2246
12"-CRU-011013004-106CS1P-H
16
2"-FLO-011013303-101CS1P-N
24
NOTE 1
18"-HFO-011015003-103CL2P-S
19
25 2673
D
250 MIN.
NOTE 1
16"x12"
25 2674
MIN.
20
101CS1P 103CL2P
UC
21
18"x12"
2"-HFO-011013025-103CL2P-S
MIN.
2"-CLD-011013303-101CH2S-P
25
2"
MIN.
103CL2P 101CH2S
MIN.
250 MIN.
106CS1P 101CH2S
D
26
2"
2"-CLD-011013317-101CH2S-P
D
MIN.
D
2"
2"
12"-HFO-011013003-103CL2P-S
22
2"-HFO-011013022-103CL2P-P
23
2"
250 MIN.
24
MIN. 2"-HFO-011013007-103CL2P-S
250 mm MIN.
25
MIN.
MIN.
2"-CRU-011013005-106CS1P-P
12"-CRU-011013002-106CS1P-H
26
27
2"
0064
MIN.
27
37 36
12"-HFO-011015003-103CL2P-S
30
10
TOPPED CRUDE TO 011-E-0017-A
2"
NOTE 3
TOPPED CRUDE 4031FROM 011-E-0015-A/B
12"-CRU-011013003-106CS1P-H
MIN.
32 31
MIN.
HPT
33
38
12"-CRU-011013003-106CS1P-H
101CS1P 103CL2P
34
2"
MIN.
35
39
7764
250 mm MIN.
36
3/4" D
V
40
TI 0293
FLO
UC
2"-CRU-011013007-106CS1P-P
37
MIN.
12"-CRU-011013014-106CS1P-H
2"
106CS1P 101CS1P
39
TT 0293
3
7 6 5 4 3
HVGO PA
2"-CLD-011013306-101CH2S-P
2"-CLD-011013305-101CH2S-P
25 25
2684
2694
12"-HFO-011013001-103CL2P-S
HVGO PA
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 2, DELETED. 1- SYMMETRICAL ARRANGEMENT. 3- H.V @ 150ºC ( SHELL AND TUBE SIDE ). 4- DELETED.
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-E-0016-A / B AES 18.00 31.70 280.00 201.40 252.00 222.70 33.10 43.00 315.00 260.00 1506.0 14.00
NOTE 3
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
TOPPED CRUDE
TO 011-S-0001
TO 011-E-0017-B
DS011-TRJR-480141 4047
DS011-TRJR-480026 3136
05
13-MAR-2013
AB
04
30-SEP-2011
03
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MVF / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS.
2
FROM 011-E-0019-A/B-D/E DS011-TRJR-480028 3138
12"-CRU-011013004-106CS1P-H
250 MIN.
250 MIN.
1
14"-HFO-011013003-103CL2P-S
103CL2P 101CH2S
106CS1P 101CH2S
2
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 TOPPED CRUDE PREHEAT - HVGO PA
011-074 011-076 Item Tags :
011-075 011-080 011-077
ORIGINAL SIGNED IN PROJECT FILE
011-E-0016-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480025.pid
Discipline: PRO
SA-JER-DS011-TRJR-480025 2271-011-PID-0021-013
REV:
05
Sheet: 2 of 3
SCALE: NONE Format:
A1
41
41
011-E-0017-A / B TOPPED CRUDE/HAGO PA EXCHANGERS
40
2" V 40
12"-CRU-011014001-106CS1P-H
INSULATION (SHELL/TUBE): H/H
HPT
39
MIN.
38
39
2"-HFO-011022002-103CL2P-P 3/4" D 2" V
36
HPT
35 34
2" 2"
TI
31
0071 LPT
30
D
103CL2P 101CH2S
2"-HFO-011014003-103CL2P-H
30
250mm MIN.
12"x10"
31
MIN. 29
LPT
2"-CLD-011014314-101CH2S-P
12"-CRU-011013003-106CS1P-H
12"-CRU-011013003-106CS1P-H
MIN.
27
MIN.
2" D
2"-HFO-011014008-103CL2P-P MIN.
UC 26
29 28
25
27
7675
MIN.
TOPPED CRUDE 3137FROM 011-E-0016-A
32
MIN.
2"-HFO-011014011-103CL2P-P
14"x12"
33
MIN.
12"
14"
32
10"-HFO-011022002-103CL2P-H
B2
A1
NOTE 5
36
MIN.
A2
011-E-0017-A
33
26
3/4" D MIN.
103CL2P 101CH2S
2"
MIN.
D
2"-CLD-011014303-101CH2S-P
23
106CS1P 101CH2S
25
HPT
21
2"-FLO-011014307-101CS1P-N
25
103CL2P 101CS1P
2"-HFO-011022002-103CL2P-P 3/4" D
2681
18
12"x10"
12"-CRU-011013004-106CS1P-H
MIN. MIN.
B2
A1
12"
14" 14"x12"
MIN.
12"x10"
12
TI
103CL2P 101CH2S
0075
2"-CLD-011014315-101CH2S-P
LPT
2"
MIN. FT
7
0013 INST. PIPING 1/2" 101CL2P 103CL2P
4
+
12" 14"x12"
14"x12"
FO
3
3/4" D
103CL2P 101CH2S
25 2686
14"-HFO-011014002-103CL2P-H
MIN.
3/4"-HFO-011014006-103CL2P-P 2"x3/4"
103CL2P 101CH2S
D
TO 011-C-0002
DS011-TRJR-480025 3136
DS011-TRJR-480044 3190
10"x8"
8" 10"x8"
IN/OUT IN/OUT
D 7
2"x3/4"
FC
6
103CL2P 101CH2S 2"-CLD-011014313-101CH2S-P
5 4
10"x8"
8"
3
6083
25
2
2685
MIN. 10"-HFO-011014001-103CL2P-H
3/4"
3/4"-HFO-011014005-103CL2P-P
TC 0079
D
103CL2P 101CH2S
2"-CLD-011014305-101CH2S-P
1
HAGO PA
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / FBL
RDP / MAC
JAL
00
11-DEC-09
IFD
IFD: ISSUED FOR DESIGN
JVM / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
FROM 011-E-0022
25
25
4953
4954
NOTES
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
MIN.
10"-HFO-011014001-103CL2P-H
2"x3/4"
2, 4, - DELETED. 1- SYMMETRICAL ARRANGEMENT. 3- DELETED. 5- H.V @ 150ºC (SHELL AND TUBE SIDE). 6- DELETED.
SHELL/TUBE SHELL/TUBE
8
25
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
011-E-0017-A / B AES 6.70 30.40 274.60 222.70 262.10 230.80 33.10 43.00 310.00 260.00 565.0 5.50
9
3/4"
3/4"
GENERAL NOTES
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
11
MIN.
3/4"
+
HAGO PA
FROM 011-E-0016-B
14"x12"
3/4"-HFO-011014010-103CL2P-P
TV 0079
3/4"
MIN.
NC
13
10
TT 0079
14"x12"
+
10"x8"
10" 14"x10"
4053
12"
2"-CLD-011014304-101CH2S-P
250mm MIN.
14"-HFO-011014007-101CL2P-H
12"-CRU-011013004-106CS1P-H
14"x10" NOTE 1
3/4" 14"x10"
CRUDE TO 011-E-0018 C/D
12
PDV 0146
2" D
2"
2"-CLD-011014306-101CH2S-P TOPPED CRUDE
14"x10"
10"-HFO-011014002-103CL2P-H
MIN.
FO
PDT 0146
10ø MIN.
4" 2
0146
12"-CRU-011014002-106CS1P-H
7674
MIN.
MIN.
5
FV 0013
1/2"
12"
250mm MIN.
6
106CS1P 101CH2S
PDC
25
MIN.
250mm MIN.
8
2"-CLD-011014302-101CH2S-P
FC 0013
250mm MIN.
9
MIN.
14"x12"
14"x12"
2"-HFO-011014004-103CL2P-H
2"-HFO-011014009-103CL2P-P
UC
14
MIN.
MIN.
2"-CRU-011014004-106CS1P-P
10
D
2"-HFO-011014012-103CL2P-P
2"
11
15
2"
MIN.
12"-CRU-011013004-106CS1P-H 13
16
MIN.
LPT
17
MIN.
14
NOTE 1
MIN.
A2
011-E-0017-B NOTE 5
18
12"
B1
15
14"x10"
250mm MIN.
16
19
2258
10"-HFO-011022002-103CL2P-H
HPT
14"
FLO
LPT
2" V
14"x12"
17
20
2500 MIN.
19
CRUDE 22 TO 011-E-0018 A/B4049
MIN.
14"-HFO-011022002-103CL2P-H
20
12"-CRU-011014001-106CS1P-H
2" V
MIN.
2"-CLD-011014301-101CH2S-P
21
23
2680
250mm MIN.
22
24
MIN.
2"-CRU-011014005-106CS1P-P
24
25
250mm MIN.
25
1
37
12"
B1
34
2249
MIN.
14"x12" 14"
38
FLO
LPT
12"x10"
35
28
103CL2P 101CS1P
37
2"-FLO-011014308-101CS1P-N
NOTE 5
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DS011-TRJR-480052 3196
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 TOPPED CRUDE PREHEAT - HAGO PA
Project:
011-074 011-076 Item Tags :
011-075 011-080 011-077
011-E-0017-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480026 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480026 2271-011-PID-0021-014
REV: 05
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
011-E-0018-A / B / C / D TOPPED CRUDE VACUUM RESIDUE EXCHANGER
40
0074
40
16"-CRU-011014003-106CS2P-H
HPT 2"
A2
106CS2P 101CH2S
29 28
14" CL600
27
TW TI 0072
CL600 B1
TT
NOTE 5
2"
LPT 12"-CRU-011014001-106CS1P-H
2250
A4
10"
14"x12"
2"-CLD-011014307-101CH2S-P
2"
CRUDE 12"-CRU-011014002-106CS1P-H 4053FROM 011-E-0017-B
MIN.
25
30
011-E-0018-C
B3
29
NOTE 5
10"
CL600 2"
TW 0298
27
CL300
26
2"
TW
B1
25
0299
CL600 A4
011-E-0018-D
24
NOTE 5
B4 10"
23 22
14"x12" LPT
21 20
MIN.
MIN.
19
D
18
103CL2P 101CH2S 3/4" D 2"-CLD-011014308-101CH2S-P
10"
31
D
A3
14"
7709
2"
106CS1P 101CH2S
250mm MIN.
106CS1P 101CH2S
TT
D
2"-HFO-011014109-103CL2P-S
UC
250mm MIN.
17
2251
1"
10"
32 FLO
MIN.
250mm MIN.
MIN.
D
2"-FLO-011014304-101CS1P-N
MIN.
2"
TI 0076
V
33
2"
HPT
A1
2"
2"-HFO-011014110-103CL2P-P
34
28
2"-CRU-011014008-106CS1P-P
2"-CRU-011014006-106CS1P-P MIN.
14"x12"
0073
LPT
2"
14"
MIN.
19
HPT
A2
7708
TI
MIN. 2"-HFO-011015103-103CL4P-S
B2
25
2"
MIN.
14"
B4
20
0076
25
103CL4P 101CH2S 2"-CLD-011014319-101CH2S-P
MIN.
15
D
MIN.
21
16
2"
MIN.
CRUDE 4049FROM 011-E-0017-A
MIN.
7707
14"
23
103CL4P 101CH2S
TW 0296
A1
0072
106CS2P 101CH2S
FLO
7706
2"
011-E-0018-B
2"-FLO-011014302-101CS1P-N
2"-CLD-011014317-101CH2S-P
2"
D
2"
2"-HFO-011014113-103CL4P-S
25
0295
25 24
2"-CLD-011014316-101CH2S-P
10" CL300
D
103CL4P 101CS1P
B3
250mm MIN.
NOTE 5
MIN.
011-E-0018-A
30
D
2"
250mm MIN.
A3
MIN.
2"-CLD-011014318-101CH2S-P
10"
2" V
2"
35
2397
3/4" D
MIN.
MIN.
2"
14"
2"-HFO-011014112-103CL4P-S
D 2"-HFO-011015103-103CL4P-S
2"-FLO-011014303-101CS1P-N FLO
1"
MIN.
B2
31
0297
10"-HFO-011015103-103CL4P-S
36
2"
12"x10"
MIN.
V
14"x12"
32
2"
TI
2"
2"-CRU-011014009-106CS2P-P
2"
33
2"-CRU-011014010-106CS2P-P
250mm MIN.
0294
HPT
2"-CRU-011014003-106CS2P-P
MIN.
TI
MIN.
2"
MIN.
2"
MIN.
26
12"x10"
3/4" D
34
NOTE 4
103CL4P 101CS1P
10"-HFO-011015103-103CL4P-S
17
TI 0077
2"-CLD-011014309-101CH2S-P
2" 16 15
25
25
25
2683
2682
2759
12"-CRU-011014002-106CS1P-H
14
13
13
12"x10" 12
NOTE 1
LPT
12"x10"
12
10"-HFO-011014102-103CL2P-S 11
MIN.
11
2"-HFO-011014111-103CL2P-P
10
UC
9
MIN. 3/4" D
8"-HFO-011014105-103CL2P-S
8
TV 0057
103CL2P 103CL4P
10
9
+
8"-HFO-011014101-103CL4P-S 8"
MIN.
8
+
1/2"
6"x4"
6"-HFO-011014103-103CL2P-S MIN.
MIN.
4
TO 011-E-0014 DS011-TRJR-480019 3109
D
2"x3/4"
MIN.
3/4"
103CL2P 101CH2S
25 7710
103CL2P 101CS1P 2"-FLO-011014305-101CS1P-N
VAC. RESIDUE
MIN.
2"-HFO-011014103-103CL2P-S
3/4"
PIPING
FO
1/2"
8" 2"-CLD-011014310-101CH2S-P
1/2"
INST. 6"x3"
FT 0063 B
3" NC
6"x3" 3/4"-HFO-011014107-103CL2P-S
MIN.
3/4" FI 0063 B
D
2"x3/4"
1"-HFO-011014106-103CL4P-S
1"
2"x1"
103CL4P 101CH2S
FLO 2245 SIGNAL
2"-CLD-011014312-101CH2S-P
FROM 011-TC-0204
DS011-TRJR-480103
25
4056
4955
DS011-TRJR-480081 3205
25
2, 3, 4 -DELETED 1- SYMMETRICAL ARRANGEMENT. 5- HV@150ºC (SHELL AND TUBE SIDE) 6- DELETED.
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
SIGNAL FROM TC 0057
DS011-TRJR-480019
DS011-TRJR-480029 3200
3983
05
13-MAR-2013
AB
MIN. AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MRM / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
IRG/STG
RDP/MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
2 1
FROM 011-E-0020
4956
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES
25
VACUUM RESIDUE
POS.
4
2760
2"-CLD-011014311-101CH2S-P VAC. RESIDUE (QUENCH) TO 011-C-0003
5
3
D
L 103CL2P 101CH2S
NC
MIN.
GENERAL NOTES
011-E-0018-A / B/ C/ D AES 16.50 29.60 302.80 229.40 265.00 244.90 33.10 43.00 NOTE 5 340.00 280.00 2484.0 10.74
MIN.
103CL2P 101CH2S
1/2"
1/2"
D
250mm MIN.
1
2"-CLD-011014320-101CH2S-P
10"-HFO-011014102-103CL2P-S
2
3/4"-HFO-011014114-103CL2P-S MIN.
3
4" 6"x4"
6
12"-HFO-011015103-103CL4P-S
LPT
MIN.
1/2"
250mm MIN.
2"
7
250mm MIN.
FV 0063
103CL2P 103CL4P
PIPING
6"-HFO-011014104-101CL2P-S
0080
D
2"-HFO-011014108-103CL2P-S
1" 103CL2P 101CL2P
0080
1/2"
1/2"
FC
INST.
0063 A
MIN.
TT
FC 0063 A
12"x10"
250mm MIN.
5
TI
FT
MIN.
6
MIN.
10ø MIN.
2"
7
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
38 37
MIN.
101CS1P 106CS2P
MIN.
MIN.
2"-FLO-011014301-101CS1P-N
2248
35
V
2"
4058
16"x12"
106CS2P 101CS1P
16"x12"
MIN.
12"-CRU-011014003-106CS2P-H
NOTE 1 FLO
TOPPED CRUDE TO 011-E-0019
MIN.
2"-CRU-011014003-106CS2P-P
36
39
2"
250mm MIN.
37
14
0074 10ø MIN.
INSULATION (SHELL/TUBE): H/H
MIN.
38
18
TI
TRIM: CRU-011014601-106CS2P / HFO-011014101-103CL4P
39
22
TT
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 TOPPED CRUDE PREHEAT - VACUUM RESIDUE
011-074 011-076 Item Tags :
011-075 011-080 011-077
011-E-0018-A/B/C/D
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480027.pid
Discipline: PRO
SA-JER-DS011-TRJR-480027 2271-011-PID-0021-014
REV:
05
Sheet: 2 of 2
SCALE: NONE Format:
A1
011-E-0019-A / B / C / D / E / F TOPPED CRUDE / HVGO PA EXCHANGERS LPT
MIN.
12"-CRU-011015017-106CL2P-H
2"
2"-CRU-011015032-106CS2P-P LPT
14" V CL300
12"
B1
A1
16
14"
2"
TI 0082
14"x12"
2"-HFO-011015005-103CL2P-S
2"-CRU-011015009-106CS2P-H
13
MIN.
B5
LPT
MIN.
2"-HFO-011015006-103CL2P-S
LPT
MIN.
MIN.
MIN. 250mm MIN.
MIN.
MIN. 2"-HFO-011015009-103CL2P-P
106CS2P 101CH2S
2"-CLD-011015306-101CH2S-P 18"x12"
25
25
25
2731
2732
2737
18"x12"
NOTE 1
NOTE 1 16"x12"
TI 0089
TT 0089
2"
18"x12"
NOTE 1
12"-CRU-011014003-106CS2P-H
HVGO PA TO 011-E-0016 DS011-TRJR-480025 3138
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
NOTE 3
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
MIN.
250 mm MIN.
103CL2P 101CS1P
2"-CRU-011015033-106CL2P-P
MIN.
101CS1P 106CL2P
MIN.
D
21 20
103CL2P 101CH2S
19 18
25 7698
12"
17 16 15 14 13
LPT
MIN.
11
V 3/4"
MIN.
12"-HFO-011015002-103CL2P-S
V 3/4"
2"-CRU-011015011-106CL2P-P
D
106CL2P 101CH2S 2"-CLD-011015304-101CH2S-P
D 103CL2P 101CH2S
2"-CLD-011015307-101CH2S-P
2733
2734
12"-HFO-011039003-103CL2P-S
2"
2"-HFO-011015007-103CL2P-S
D
103CL2P 101CH2S
9
MIN.
MIN. 2"
UC
UC
10
2"
8 7 6 5
2"-CLD-011015308-101CH2S-P 25
25
2735
2736
4 3 2
10"-HFO-011015004-103CL2P-S 18"-HFO-011039003-103CL2P-S NC 2" 2"-HFO-011015013-103CL2P-S
PIPING. 1/2"
2" MIN.
D
103CL2P 101CH2S
25
INST.
1
TT 0240
TI 0240
FT 0064
FI 0064
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
HVGO PA
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
FROM 011-G-0017
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
ARV / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
1/2"
DS011-TRJR-480101 3210
7704
NOTES
011-E-0019-A - F AES 19.40 27.90 322.90 244.10 280.00 276.10 33.10 43.00 355.00 310.00 2836.0 22.75
MIN.
25
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
2"
LPT
2"-HFO-011015008-103CL2P-S
25
GENERAL NOTES
1- SYMMETRICAL ARRANGEMENT. 2- TO MIN DISTANCE FROM OUTLET NOZZLE. 3- H.V.@150ºC (SHELL AND TUBE SIDE). 4- DELETED.
22
MIN.
12"-HFO-011015003-103CL2P-S
250 mm MIN. MIN.
18"x12"
12"-HFO-011015003-103CL2P-S 16"x12"
2738
D
2"-CLD-011015303-101CH2S-P
2"-CLD-011015302-101CH2S-P 2"-CLD-011015305-101CH2S-P
LPT
25
1
106CL2P 101CH2S
103CL2P 101CH2S
MIN.
2
103CL2P 101CH2S
2"-CLD-011015322-101CH2S-P
3
D
UC
2"
D
2"
V 3/4"
MIN.
MIN.
2"-CRU-011015012-106CL2P-P
D
23
12
2"
10ø MIN.
4
UC
2"
250mm MIN.
5
12"-HFO-011015001-103CL2P-S
24
B5
14"
2"
TW 0307
TI 0087
LPT
MIN.
MIN.
MIN.
250mm MIN.
2"-CLD-011015301-101CH2S-P
6
250mm MIN.
7
V 3/4"
12"-CRU-011014003-106CS2P-H
106CS2P 101CH2S
2"-CRU-011015025-106CS2P-P
MIN. D
9
MIN.
2"
MIN. LPT
2"-CRU-011015010-106CS2P-H
11
MIN.
2"
14"x12"
12" A5
A2
NOTE 3
12"
TW 0306
011-E-0019-E
B6
14"
12"
14"
2"
14" B2
A6
A1
12
10
MIN.
B1
CL300
2"
0305
12"
011-E-0019-F
A2
2"
LPT
LPT
14
TW 0303
CL600
TW 14"
7734
MIN.
15
NOTE 3
12"
B4 12"
A3
V
HPT
25
12" A5
011-E-0019-B
B6
2"
TW 0302
14" B2
A6
011-E-0019-C
17
0301
12" A4
MIN.
TW 14"
18
2"
NOTE 3
25
MIN.
011-E-0019-D
HPT
MIN.
2"
14"-CRU-011015003-106CL2P-H
26
HPT
HPT 2" V
B3
V
28 27
14"
2"-CLD-011015319-101CH2S-P
19
2"
250mm MIN.
CL600
D
103CL2P 101CH2S
20
2" 2"
MIN. 2"-HFO-011015010-103CL2P-P
21
MIN.
MIN. 2"-CRU-011015026-106CS2P-P
14"-CRU-011015002-106CL2P-H
7699
3/4"
30 29
2297
12"-HFO-011039003-103CL2P-S
B4 12"
A3
25
14"
2"
MIN.
NOTE 3
D
FLO
MIN.
A4
D
106CL2P 101CH2S
2"-FLO-011015304-101CS1P-N
2"-HFO-011039003-103CL2P-S
2"
MIN.
B3
011-E-0019-A
MIN.
250mm MIN.
12"
TW 0304
250mm MIN.
0300
2"
NOTE 2
2"
2"-CLD-011015321-101CH2S-P
14"
2" V
0309
31
MIN.
2"-CLD-011015320-101CH2S-P
V
TW
2"
2"
TI
7703
2"
2"-HFO-011015011-103CL2P-S
14"x12"
34
MIN.
MIN.
HPT
35 4060
32
250mm MIN.
2"
TOPPED CRUDE TO 011-E-0020A-F
2"
14"x12"
25
22
2243
3/4" D
7733
2"-CLD-011015317-101CH2S-P
23
3/4"
25
LPT
26
24
FLO 2296
FLO
2"-CRU-011015004-106CL2P-P
2"-FLO-011015303-101CS1P-N
12"-CRU-011015004-106CL2P-H
D
25
0308
250 mm MIN.
MIN.
NOTE 2 2"
TI
2"-FLO-011015302-101CS1P-N
12"-HFO-011039003-103CL2P-S
27
MIN.
2"-HFO-011039003-103CL2P-S
106CL2P 101CH2S
28
2"-CLD-011015318-101CH2S-P
103CL2P 101CS1P
3/4" D
106CS2P 101CH2S
MIN.
2244
29
MIN.
MIN.
16"-CRU-011015004-106CL2P-H
33
HPT
2" 2" D
NOTE 1
LPT
2" V
250 mm MIN.
101CS1P 106CL2P
2"-CRU-011015004-106CL2P-P
2"
36
16"x12"
2" D
MIN.
2"-FLO-011015301-101CS1P-N
FLO
8
16"x12"
MIN.
250 mm MIN.
MIN.
31 30
MIN. 2"-CRU-011015031-106CL2P-P
32
HPT
37
2" 10ø MIN. 12"-CRU-011015004-106CL2P-H
MIN.
33
V
2"
16"-CRU-011014003-106CS2P-H
34
0083
2"
36 35
38
TT
250 mm MIN.
37
39
NC
106CS2P 106CL2P
TOPPED CRUDE FROM 011-E-0018 4058
40
TI 0083
2"
12"-CRU-011015001-106CS2P-H
39 38
INSULATION (SHELL/TUBE): H/H TRIM: CRU-011015601-106CL2P TRIM: HFO-011015601-103CL2P
2"
40
41
2"-HFO-011015012-103CL2P-S
41
05
13-MAR-2013
AB
04
30-SEP-2011
03
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
FLUSHING OIL
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 TOPPED CRUDE PREHEAT - HVGO PA
011-074 011-076 Item Tags :
011-075 011-080 011-077
ORIGINAL SIGNED IN PROJECT FILE
011-E-0019 A/B/C/D/E/F
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480028.pid
Discipline: PRO
SA-JER-DS011-TRJR-480028 2271-011-PID-0021-015
REV:
05
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
011-E-0020-A/ B/ C/ D/ E/ F TOPPED CRUDE / VACUUM RESIDUE EXCHANGERS
40
0084
MIN.
10"-CRU-011015008-106CL2P-H
LPT
38
NC
38
TT 0084
2" 37
2"-CRU-011015035-106CL2P-P 16"x12"
MIN.
12"-CRU-011015007-106CL2P-H
2" V
14"x12" 14"
B4 10"
A3 14"
TW
0313
2"-CRU-011015013-106CL2P-H
25
14" 14"x12"
2"-HFO-011015108-103CL4P-S
MIN. 0319
5 25
4
2740
3 2
2"-CLD-011015313-101CH2S-P
25
25
25
2741
2739
2743
10"-HFO-011015103-103CL4P-S
12"x10"
TI 0085
12
2"
MIN.
MIN.
103CL4P 101CH2S
106CL2P 101CH2S
2"-CLD-011015311-101CH2S-P
106CL2P 101CH2S
2"-CLD-011015316-101CH2S-P
25
25
25
25
2744
2745
2742
2746
8 7 6 5 4
10"-HFO-011039103-103CL4P-S
3 2
TO 011-F-0001 DS011-TRJR-480311 4062
2" CL600
NC
TT
TI
0242
0242
MIN.
2"
12"-HFO-011039103-103CL4P-S
250mm MIN.
103CL4P 101CH2S 2"-CLD-011015326-101CH2S-P 25
VAC. RESIDUE FROM 011-G-0018 DS011-TRJR-480103 3223
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
103CL4P 101CH2S
2"-CLD-011015312-101CH2S-P 2"-CLD-011015315-101CH2S-P
1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
ARV / STG
RDP / MAC
JAL
REV
7770
NOTE 3
10
D
LPT
2"
DS011-TRJR-480027 3200
IN/OUT IN/OUT
2"
D
D
11
2"-HFO-011015113-103CL4P-S
TO 011-E-0018
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
MIN.
2"
2"
D
1- SYMMETRICAL ARRANGEMENT. 2- TO MIN. DISTANCE FROM OUTLET NOZZLE. 3- H.V @ 150ºC (SHELL AND TUBE SIDE). 4- DELETED.
2"-CRU-011015016-106CL2P-P
MIN.
MIN.
1" D
TOPPED CRUDE
MIN.
TT 0085
VAC. RESIDUE
SHELL/TUBE SHELL/TUBE
2"-HFO-011015106-103CL4P-S
10"-HFO-011015103-103CL4P-S
MIN.
NOTE 1
3/4" D
12"x10"
NOTE 1 12"x10"
12"-CRU-011015004-106CL2P-H
011-E-0020-A - F AES 17.50 25.60 360.00 276.10 308.00 298.00 33.10 43.00 390.00 330.00 3539.0 15.80
15
LPT
9
12"x10" NOTE 1
16"x12"
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
7771
16
250mm MIN.
2"-CLD-011015310-101CH2S-P
2"-CLD-011015314-101CH2S-P
10ø MIN.
16"x12" 16"-CRU-011015004-106CL2P-H
17
25
13
250mm MIN.
103CL4P 101CH2S
106CL2P 101CH2S
10"-HFO-011015104-103CL4P-S
1
2"-CLD-011015328-101CH2S-P
UC
D
MIN.
MIN.
MIN.
D
250mm MIN.
2"-CLD-011015309-101CH2S-P
18
MIN.
2"
2"
D
103CL4P 101CH2S
12"-CRU-011015004-106CL2P-H
6
2"
D
250mm MIN.
250mm MIN.
7
MIN.
MIN.
250mm MIN.
2"
106CL2P 101CH2S
8
2"-CRU-011015014-106CL2P-P
MIN.
250mm MIN.
1" D MIN.
MIN.
9
19
10"-HFO-011015102-103CL4P-S
10"-HFO-011039103-103CL4P-S
MIN.
D
20
B5 10"
A2
UC 3/4" D
10" A5
MIN. 2"-HFO-011015110-103CL4P-P
UC
2"
14" B2
10"-HFO-011015101-103CL4P-S
12
10
TW 0318
2"
14
2"-HFO-011015109-103CL4P-P
MIN.
103CL4P 101CH2S
2"-HFO-011015107-103CL4P-S
MIN.
MIN.
UC
22
2"
LPT
2"-CRU-011015028-106CL2P-P
11
23
2" D
LPT
TW
0320
2"-CRU-011015015-106CL2P-H
13
2"-CRU-011015027-106CL2P-P
MIN.
14"
2"
TI LPT
LPT
MIN.
MIN.
25
2"
24
2"
NOTE 3
7773
2"-HFO-011015105-103CL4P-S
14
26
CL300
011-E-0020-E
B6 10"
A1
2"-CLD-011015325-101CH2S-P
LPT
V
10" A6
NOTE 3 10"
2"
CL600
LO
16"-CRU-011015007-106CL2P-H
LPT
TW
2"
HPT 10" A4
MIN.
15
TI 0315
V
2"-HFO-011015112-103CL4P-S
0317 14"
011-E-0020-F
LPT
2"
14"-CRU-011015006-106CL2P-H
TW
B5
14"
25 7780
HPT
B1
A2
LO
HPT
10" A5
MIN.
14"x12"
NOTE 3
27
LPT
21
103CL4P 101CH2S
0312
011-E-0020-B
B6 10"
A1 14"
2"
28
B4 10"
A3 14"
V
2"-FLO-011015309-101CS1P-N
MIN.
250mm MIN.
NOTE 3
NOTE 3
30
2301
D
106CL2P 101CH2S
011-E-0020-D
2"
2" 14" B2
A6
011-E-0020-C
D
CL300
2"
TW
10"
B1
2" 2"
0311 14"
250mm MIN.
MIN.
250mm MIN.
HPT
16
TW
1"
29
B3
V
2"
17
14"
2"-HFO-011015111-103CL4P-S
20
14"x12"
LO
2"
14"-CRU-011015005-106CL2P-H
21
18
LO
A4
CL600
19
2"
10"
HPT
22
V
HPT
V
MIN.
2"
25 7779
HPT
2"
12"-CRU-011015007-106CL2P-H
0316
NOTE 3
2" V
23
NOTE 2
LPT
011-E-0020-A
0310
24
MIN.
2"
31 FLO
D
TI 0321
B3
TW
3/4" D
7783
MIN.
25
25
2"
MIN.
HPT
2300
32
250mm MIN.
2"
TI 0314
D
FLO
2299
2"-CRU-011015007-106CL2P-P
2"-FLO-011015308-101CS1P-N
MIN.
2"-HFO-011039103-103CL4P-S MIN.
2"-CLD-011015327-101CH2S-P
NOTE 2
1"
FLO
2"-CRU-011015036-106CL2P-H
MIN.
D 3/4"
2"-FLO-011015305-101CS1P-N
33
2"
MIN.
250mm MIN.
106CL2P 101CH2S
250mm MIN.
2298
2"-HFO-011039103-103CL4P-S
103CL4P 101CS1P
2"-CRU-011015007-106CL2P-P
2"-FLO-011015306-101CS1P-N 101CS1P 106CL2P
FLO
2"-CLD-011015323-101CH2S-P
26
D 16"-CRU-011015004-106CL2P-H
27
MIN.
2"
31
28
MIN.
101CS1P 106CL2P
MIN. MIN.
106CL2P 101CH2S 2"-CLD-011015324-101CH2S-P
MIN.
34
MIN.
2"-CRU-011015034-106CL2P-P
32
29
16"x12" LPT
D
MIN.
2"
33
30
35
MIN. 2"
34
36
2"
NOTE 1
MIN.
TOPPED CRUDE 4060 FROM 011-E-0019 A/F
MIN.
35
37
10ø MIN.
LPT
36
39
103CL4P 101CS1P
39
40
TI
TRIM: CRU-011015602-106CL2P / HFO-011015101-103CL4P INSULATION (SHELL/TUBE): H/H
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
FLUSHING OIL
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 TOPPED CRUDE PREHEAT - VAC. RESIDUE
011-074 011-076 Item Tags :
011-075 011-080 011-077
011-E-0020 A/B/C/D/E/F
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480029 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480029 2271-011-PID-0021-015
REV: 05
Sheet: 2 of 3
SCALE: NONE Format:
A1
41
41
RESET
40
ZHSR
ZC
0003
0330
39
ZHXS ES 0003
38
+
0332
BY VENDOR 40
ZPZV 0018
ZHXS ES
ZC
NOTE 13
1/2"D3/4" 12.00 +
39
V
0003 L 38
NOTE 2 1"-IAI-011016301-301CG2P-N
37
BY-PASS
CLOSED
ZYV 0003 +
36
ZHA
ZYC
ZLO
ZLC
0003
0003
0003
0003
S
INST.
37
NOTE 12
1"-IAI-011220302-301CG2P-N
ZLS 0003 O
ATM
ZLS 0003 C
10
34
D
ZV 0003
3/4"
+
33 32
35
6"-MPS-011016304-103CS1P-H
ZY 0003
8"-MPS-011016301-103CS1P-H
2215
31
6"
EMERGENCY STEAM
FC TSO NOTE 8
D
3/4"
ST 30 29
3/4" D
3/4"
D
3/4"
31 30
28
3/4" D
27
RO 0001 +
NC
ZC 0332
26
26
25
25
103CS1P 103CL2P
24
24
FT
1/2"
1/2"
MIN.
FC 0015 A
L FV 0015 A +
21
6"-CRU-011015018-106CL2P-H
1/2"
1/2"
1/2"
1/2"
FT
6"x4"
ZC 0330
14
4"
17
6"x4"
16
3/4"
0015 AC
FI 0015 A
3/4"-CRU-011016002-106CL2P-P
15
D
2"x3/4" LL
12
FC 0015 B
11
106CL2P 101CH2S
14 13
250 mm MIN.
ZC 0332
13
FMC
RO 0002
12
+
2"-CLD-011016301-101CH2S-P
L
11
10
103CS1P 103CL2P
25
FT
FY
0015 BA
0015 B
1/2"
1/2"
7
MIN. FV 0015 B +
6"x4"
1/2"
1/2"
1/2"
FROM 011-E-0020 DS011-TRJR-480311 5533
SIGNAL
SIGNAL
SIGNAL
SIGNAL
SIGNAL
SIGNAL
FROM TY-0097 A
TO TY-0097 AA
TO FY-0014 A
FROM TY-0097 B
TO FY-0014 A
TO TY-0097 AA
DS011-TRJR-480311
DS011-TRJR-480034
DS011-TRJR-480311
DS011-TRJR-480035
DS011-TRJR-480311
DS011-TRJR-480034
5541
5509
5542
5545
5544
5510
MIN. NOTE 3
FO 4"
INST
6"-CRU-011017003-103CL2P-H
FT 0015 BB FT FI
0330
0015 B
4"
3/4"
3/4"-CRU-011016003-106CL2P-P
0015 BC
ZC
6 5 4
6"x4"
NC
MIN. 2oo3
7
3
6"x4"
D
2"x3/4" LL
106CL2P 101CH2S
TOPPED CRUDE FROM 011-E-0020
250 mm MIN.
TOPPED CRUDE
6"-CRU-011015019-106CL2P-H
6"-CRU-011015018-106CL2P-H
4
8
6"-CRU-011017003-103CL2P-H
PIPING
1/2"
6"x4"
MIN.
PASS 2 6"-CRU-011015019-106CL2P-H
5
9
LO
2"-CLD-011016302-101CH2S-P
DS011-TRJR-480311 5534
TOPPED CRUDE
TOPPED CRUDE
TO 011-F-0001
TO 011-F-0001
DS011-TRJR-480035 3233
DS011-TRJR-480034 3230
2 1
MIN.
6
10
4964
106CL2P 103CL2P
8
PIPING INST.
9
20
NC
MIN.
FT
2oo3 15
6"-CRU-011016001-103CL2P-H NOTE 3
18
0015 AB
16
21
19
INST.
18 17
MIN.
6"x4"
PIPING
19
22
FO 4"
MIN.
20
6"-CRU-011016001-103CL2P-H
MIN.
PASS 1
6"x4"
23
6"-CRU-011016001-103CL2P-H
22
FY 0015 A
LO
FMC
106CL2P 103CL2P
PIPING INST.
0015 AA 23
1
32
29
3/4"
27
2
33
13
28
3
36
6277
MFR. PIPING
PIPING. MFR.
DE
ZHS 0003
4077
17
35 34
EMERGENCY STEAM TO PASS 3 TO 8
8"-MPS-011016301-103CS1P-H
PIPING
6"-MPS-011016302-103CS1P-H
OPEN
ZPI 0003 A
06
13-MAR-2013
AB
AB : AS BUILT
MJR / STG
AVS / HCR
JAL
05
06-OCT-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MRM / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
APPR/AUTH BY
25 4963
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAIN SYSTEMS SHALL BE GRAVITY FLOW DESIGNED.
UTILITIES IDENTIFICATION POS.
1 2 3 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 4 5 NOTES 6 1,4,5,6,7,9,10,11 DELETED. 7 2- LOCAL EMERGENCY SWITCH BEHIND FIREWALL OR IN SAFE LOCATION. 8 3- TWO PHASES FLOW DURING TURNDOWN. 9 8- ZV-0003 TO BE LOCATED AT MINIMUM DISTANCE FROM INJECTION POINT. 10 12- AIR VESSEL TO ALLOW 3 FULL STROKES CAPACITIES. AND SHALL BE LOCATED OUTSIDE THE FIRE HAZARDOUS AREA. 11 13- 1002D VOTING LOGIC BETWEEN SIGNALS ZHSX-0003-A (PIB) AND ZHSX-0003-B(MCB). 12 13 14 15 16 17 18 This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
REF. DWG
011-075
JUBAIL EXPORT REFINERY 011-078
PIPING AND INSTRUMENT DIAGRAM Project:
011-074 011-076 011-075 011-080
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE HEATER INLET ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480030.pid
Discipline: PRO
SA-JER-DS011-TRJR-480030 2271-011-PID-0021-016
REV:
06
Sheet: 1 of 4
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
37
8"-MPS-011016301-103CS1P-H
8"-MPS-011016301-103CS1P-H
EMERGENCY STEAM TO PASS 5 TO 8
36 4077 35
FY 0015 C
33
FT
FC 0015 C
FMC L
ZC 0332
0015 CA
32
1/2"
1/2"
1/2"
1/2"
106CL2P 103CL2P
31
FV 0015 C +
30
PASS 3
6"x4"
6"-CRU-011015020-106CL2P-H
28
+
33
103CS1P 103CL2P
32
LO
31 30
MIN.
4" 6"x4"
29
NOTE 2
FO
MIN.
29
34
RO 0029
MIN.
FT 0015 CC
36 35
6"-MPS-011016306-103CS1P-H
6"-MPS-011016308-103CS1P-H
34
4142
28
27
27
1/2"
1/2"
26
6"x4" FT 0015 CB
2oo3 ZC 0330
24
NC
MIN. 3/4"-CRU-011016004-106CL2P-P
FI 0015 C
25
3/4" D
2"x3/4"
LL
26
6"x4"
24
MIN.
25
4"
23
23
106CL2P 101CH2S
21
2"-CLD-011016303-101CH2S-P
20
22
250mm MIN.
22
21 20
25 4967
19
19
18
18
17
17
16
16
RO 0030 +
15
15
103CS1P 103CL2P
14
14
12
FT
LO FY
FC
0015 D
0015 D
FMC
13
ZC 0332
L
12
0015 DA 11
1/2"
1/2"
1/2"
FV 0015 D +
9
6"x4"
PASS 4 6"-CRU-011015021-106CL2P-H
9
MIN.
4" 6"x4" 8
NOTE 2
FO
MIN.
8
10
6"-CRU-011017005-103CL2P-H
1/2"
106CL2P 103CL2P
10
11
7
1/2"
1/2" 6"x4"
5
2oo3 ZC 0330
3
TOPPED CRUDE FROM 011-E-0020 DS011-TRJR-480311 4078
SIGNAL
SIGNAL
SIGNAL
SIGNAL
SIGNAL
SIGNAL
TO FY-0014 A
TO TY-0097 AA
FROM TY-0097 C
FROM TY-0097 D
TO FY-0014 A
TO TY-0097 AA
DS011-TRJR-480311
DS011-TRJR-480034
DS011-TRJR-480036
DS011-TRJR-480037
DS011-TRJR-480311
DS011-TRJR-480034
4082
5500
5497
5501
4084
5499
D
2"x3/4"
106CL2P 101CH2S
5 4 3
25 4968
TOPPED CRUDE FROM 011-E-0020 DS011-TRJR-480311 5536
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAIN SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1,3,4 DELETED. 2- TWO PHASES FLOW DURING TURNDOWN.
6
TOPPED CRUDE
2
TO 011-F-0001
TO 011-F-0001
DS011-TRJR-480037 3187
DS011-TRJR-480036 3178
1
2"-CLD-011016304-101CH2S-P
GENERAL NOTES
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
3/4"
TOPPED CRUDE
6"-CRU-011015021-106CL2P-H
1
3/4"-CRU-011016005-106CL2P-P
LL
6"-CRU-011015020-106CL2P-H
2
NC
MIN.
FI 0015 D
6"x4"
250mm MIN.
4
FT 0015 DB
4"
7
MIN.
6
6"-CRU-011017004-103CL2P-H
FT 0015 DC
MIN.
13
05
13-MAR-2013
AB
AB : AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MRM / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE HEATER INLET ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480031.pid
Discipline: PRO
SA-JER-DS011-TRJR-480031 2271-011-PID-0021-016
REV: 05
Sheet: 2 of 4
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
37
EMERGENCY STEAM
NOTE 3
8"-MPS-011016301-103CS1P-H
EMERGENCY STEAM TO PASS 7 AND 8
36 4142FROM HEADER
4147
6"-MPS-011016310-103CS1P-H 6"-MPS-011016312-103CS1P-H
35 34
FY 0015 E
33
FC 0015 E
32
FMC L
ZC 0332
FT 0015 EB
31
FT 0015 EA
30
1/2"
1/2"
FV 0015 E +
6"x4"
1/2" 2oo3
25
ZC 0330
24
32 31
103CS1P 103CL2P
30
28
MIN.
4" 6"x4"
6"-CRU-011017006-103CL2P-H NOTE 2
27 26
1/2"
25
6"x4"
FT 0015 EC
LL
29
1/2" 1/2"
PIPING INST.
FI 0015 E
33
FO
MIN.
6"-CRU-011015022-106CL2P-H
26
+
22
24
6"x4"
NC
MIN. 3/4"-CRU-011016006-106CL2P-P
23
4"
23
3/4" D
2"x3/4"
22
MIN.
PASS 5
34
RO 0031
MIN.
1/2"
28 27
35
LO 106CL2P 103CL2P
INST. PIPING 1/2"
29
36
21
+
19
250mm MIN.
106CL2P 101CH2S
20
21
RO 0032
2"-CLD-011016305-101CH2S-P
20 19
18
18 25
17
17
4969
16
16
103CS1P 103CL2P
15 14 13
FY
FC
0015 F
0015 F
FMC L
LO
14
ZC 0332
13
FT
11
12
MIN.
FT 0015 FB
12
15
11
0015 FA INST. PIPING 1/2" 1/2"
10
FV 0015 F
8
6"x4"
+
6"-CRU-011015023-106CL2P-H MIN.
7
1/2" 6
2oo3 ZC
FI
0330
0015 F LL
4
1
PIPING 1/2" INST.
1/2"
TOPPED CRUDE FROM 011-E-0020 DS011-TRJR-480311 4143
SIGNAL
SIGNAL
SIGNAL FROM TY-0097E
TO TY-0097 BA
SIGNAL TO FY-0014B
SIGNAL FROM TY-0097F
TO TY-0097 BA
SIGNAL TO FY-0014B
DS011-TRJR-480311
DS011-TRJR-480038
DS011-TRJR-480311
DS011-TRJR-480039
DS011-TRJR-480038
DS011-TRJR-480311
4066
5504
4068
4070
5503
4072
6"x4"
FT
6"-CRU-011015023-106CL2P-H
2
4"
6"x4"
NC
MIN. 3/4"-CRU-011016007-106CL2P-P
3/4" D
2"x3/4"
106CL2P 101CH2S 2"-CLD-011016306-101CH2S-P
25
TOPPED CRUDE
4970
FROM 011-E-0020 DS011-TRJR-480311 5537
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAIN SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1,3,4 DELETED 2- TWO PHASES FLOW DURING TURNDOWN.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
NOTE 2
FO
1/2"
0015 FC
6"-CRU-011015022-106CL2P-H
3
8
05
13-MAR-2013
AB
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
6 5 4 3
TOPPED CRUDE
TOPPED CRUDE
TO 011-F-0001
TO 011-F-0001
DS011-TRJR-480039 3197
DS011-TRJR-480038 3191
2 1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MRM / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MRM / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MRM/STG
RDP/MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS.
7
250mm MIN.
5
MIN.
4" 6"x4"
MIN.
PASS 6
9
6"-CRU-011017007-103CL2P-H
9
6"-CRU-011017006-103CL2P-H
1/2" 1/2"
106CL2P 103CL2P
10
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE HEATER INLET
011-076 011-075 011-080
Item Tags :
ORIGINAL SIGNED IN PROJECT FILE
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480032.pid
Discipline: PRO
SA-JER-DS011-TRJR-480032 2271-011-PID-0021-016
REV: 05
Sheet: 3 of 4
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
37
EMERGENCY STEAM 36
8"-MPS-011016301-103CS1P-H
36
4147 FROM HEADER
8"x6"
35
35
6"-MPS-011016314-103CS1P-H
6"-MPS-011016301-103CS1P-H
34 33 32
0015 GA 30
1/2"
29
FY
FC
0015 G
0015 G
INST. PIPING
1/2"
FMC L
ZC
+
PASS 7
4"
6"x4"
6"-CRU-011015024-106CL2P-H
26
+
31
103CS1P 103CL2P
30
LO
29 28
MIN.
6"x4"
27
NOTE 2
FO
MIN.
27
32
RO 0043
0332
FV 0015 G
28
33
MIN.
FT
106CL2P 103CL2P
31
34
26
25
25
1/2"
1/2"
23
24
1/2" PIPING INST.
6"x4"
21
FI 0015 G
D
2"x3/4" LL
FT 0015 GC
20
22
20
106CL2P 101CH2S
19
2"-CLD-011016307-101CH2S-P 18 17
21
250mm MIN.
ZC 0330
3/4"
3/4"-CRU-011016008-106CL2P-P
0015 GB
2oo3
22
23
NC
MIN.
FT
6"x4"
4"
MIN.
1/2" 24
19
RO 0044 +
18
103CS1P 103CL2P
25
17
4971
16
16
LO
15
14
14
FT 0015 HA 1/2"
11
1/2"
FC
0015 H
0015 H
INST. PIPING
FMC L
0332
12
106CL2P 103CL2P
+
10
PASS 8
13
11
FV 0015 H 6"x4"
6"-CRU-011015007-106CL2P-H
8
10
MIN.
4" 6"x4"
9
NOTE 2
FO
MIN.
9
ZC
8
7
1/2" 1/2"
1/2"
6
PIPING INST.
6"x4"
5
FT 2oo3
3
FI 0015 H
TOPPED CRUDE FROM 011-E-0020 DS011-TRJR-480311 4148
FT 0015 HC
106CL2P 101CH2S
6"-CRU-011015007-106CL2P-H
1
6"-CRU-011015024-106CL2P-H
2
SIGNAL
SIGNAL
SIGNAL FROM TY-0097G
TO TY-0097 BA
SIGNAL TO FY-0014B
SIGNAL FROM TY-0097H
TO TY-0097 BA
SIGNAL TO FY-0014B
DS011-TRJR-480040
DS011-TRJR-480038
DS011-TRJR-480311
DS011-TRJR-480041
DS011-TRJR-480038
DS011-TRJR-480311
4073
5505
4075
4074
5506
4076
2"-CLD-011016308-101CH2S-P
6 5 4 3
05
13-MAR-2013
AB
04
30-SEP-2011
TOPPED CRUDE
03
FROM 011-E-0020 DS011-TRJR-480311 5538
4972
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAIN SYSTEMs SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1,3,4 DELETED. 2- TWO PHASES FLOW DURING TURNDOWN.
7
TOPPED CRUDE
TOPPED CRUDE
TO 011-F-0001
TO 011-F-0001
DS011-TRJR-480041 3209
DS011-TRJR-480040 3204
2 1
25
GENERAL NOTES
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
D
2"x3/4" LL
3/4"
250mm MIN.
ZC 0330
3/4"-CRU-011016009-106CL2P-P
0015 HB
6"x4"
NC
MIN.
4
4"
MIN.
1/2"
6"-CRU-011017008-103CL2P-H
12
FY
6"-CRU-011017009-103CL2P-H
13
MIN.
15
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MRM / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MRM / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE HEATER INLET
Project:
011-074
011-076 011-075 011-080
Item Tags :
ORIGINAL SIGNED IN PROJECT FILE
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480033 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480033 2271-011-PID-0021-016
REV: 05
Sheet: 4 of 4
SCALE: NONE Format:
A1
41
41
011-F-0001 CRUDE HEATER
40
40
39
39
38
38
TRJR
VENDOR
37
37
VENDOR
TRJR
36
36 SIGNAL
35
FROM TC-0097 B 6347
STRIPPING STEAM FROM HEADER
34
16"
12"
33
TI 0092 A
32
NOTE 1
31
STRIPPING STEAM TO 011-C-0002
SEE DWG. DS011-TRJR-480042
H
TE 0092 A
TI 0093 A
NOTE 4 SKIN
34 33
SIGNAL
TE
TO TC-0097 B
0093 A SKIN NOTE 4
6348
32 31
V
NOTE 2
30
30
PI
29
0027 A TI
28
TC 0097 AA
H
29 28
0094 A PI 0026 A
27
PT 0027 A
27
TE SKIN 0094 A NOTE 4
26 25
3/4"
3/4"
INST. PIPING
26
6"-CRU-011017401-103CL2P-H
25
X
TY
24
35
PASS 1
24
0097 AA
23
23
22
TE 0095 A
21
NOTE 4 SKIN
20
TI 0095 A
22
H
21
ZC TI
H
20
0330
0096 A
19
19
SP
18
TI
TE 0096 A SKIN NOTE 4
17
0100 A
16
HH
18
H
TC 0097 A
17 16
NOTE 1 CL300
NOTE 2
15
TT 0100 A
D 14
14"x6" NOTE 6
13
011-F-0001
11
14
CL300 2"
CL300 2"
13 12
MIN.
12
15
TT 0097 A
11
2"
10
2"
MIN.
9
10
MIN.
2"-CRU-011017010-101CL2P-P
9
D
8
8
250mm MIN.
101CL2P 101CH2S
7 6
7 6
2"-CLD-011017301-101CH2S-P
5
5 25 7700
4
4
3
3 SIGNAL
SIGNAL
SIGNAL
SIGNAL
SIGNAL
FROM FC-0015D
FROM TC-0097 C
TO TC-0097 C
FROM TC-0097 D
TO TC-0097 D
DS011-TRJR-480031
DS011-TRJR-480036
DS011-TRJR-480036
DS011-TRJR-480037
DS011-TRJR-480037
SIGNAL TO AIR/FUEL RATIO SYSTEM DS011-TRJR-480115
5500
6337
6338
6339
6340
6341
1
14"-CRU-011017002-101CL2P-H
6"-CRU-011016001-103CL2P-H
2
TOPPED CRUDE TOPPED CRUDE
FROM 011-E-0020
TO 011-C-0002
DS011-TRJR-480030 3230
DS011-TRJR-480041 3213
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- CONNECTION FOR PIGGING (MECHANICAL DECOKING SYSTEM). SPOOL PIECE REPLACED BY PIGGING ELBOW DURING MAINTENANCE. 2- SPOOL PIECES SHALL BE MINIMUM DISTANCE FROM THE HEATER. 3- OP. TEMP.: 281 TO 366º AND OP. PRESS.: 11.2-2.0 barg. 4- SKIN THERMOCUPLE SUPPLY BY VENDOR. 5- COIL MATERIAL: 5Cr+3mm. 6- SPOOL MATERIAL BY TRJR.
HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
011-F-0001 barg °C barg Gcal/h
11.20 281.00 20.50 84.70
NOTE 5 NOTE 3 NOTE 3
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
SIGNAL
SIGNAL
SIGNAL
SIGNAL
TO TY-0097A
FROM FC-0015A
FROM FC-0015B
FROM FC-0015C
DS011-TRJR-480311
DS011-TRJR-480030
DS011-TRJR-480030
DS011-TRJR-480031
5508
5509
5510
5499
05
13-MAR-2013
AB
04
30-SEP-2011
03
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / SGT
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / SGT
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MMG / SGT
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS.
2
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 011-075 011-080
Item Tags : 011-F-0001
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE HEATER PASS 1 - PROCESS COIL ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480034 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480034 2271-011-PID-0021-017
REV: 05
Sheet: 1 of 9
SCALE: NONE Format:
A1
41
41
40
40
011-F-0001 CRUDE HEATER
39
39
38
38
37
37
36
36 SIGNAL
35 6347 TO TY-0097 AA
35
34
34
33
33
SIGNAL 6348 FROM TY-0097 AA
32
32
31
31
30
TRJR
30
VENDOR
VENDOR
TRJR
29
29
28
28
PI 0027 B
27
STRIPPING STEAM FROM HEADER
TI 0092 B
25
PT
PI 0026 B
24 23
INST. PIPING
22
3/4"
0027 B
INST. PIPING
16"
12"
26
NOTE 1
H
TE 0092 B
26
TI 0093 B
SKIN NOTE 4
27
STRIPPING STEAM TO 011-C-0002
SEE DWG. DS011-TRJR-480042
TE 0093 B
V
25
SKIN NOTE 4
24 23
NOTE 2 3/4" TI
22
H
0094 B
21
PASS 2
21
6"-CRU-011017003-103CL2P-H
20
20 19
19
TE 0094 B SKIN NOTE 4
18
18
17
17
6"-CRU-011017402-103CL2P-H 16
16
15
15
14
TE
TI
13
0095 B
0095 B
12
SKIN NOTE 4
13
ZC 0330
12
TI
11
14
H
SP
H
0096 B TI 0100 B
10
TC 0097 B
HH
H
11
OP
TY 0097 B
10
TE
9
9
0096 B SKIN NOTE 4
8
8
NOTE 1 CL300
7
NOTE 2 6
TT
TT
0100 B
0097 B
7 6
D CL300 2"
14"x6" 5
NOTE 6
5 4
MIN.
011-F-0001
4
CL300 2"
2" MIN. 2"
2"-CRU-011017011-101CL2P-P
D 101CL2P 101CH2S
250 mm MIN.
1
MIN.
6"-CRU-011017003-103CL2P-H
2
3
14"-CRU-011017002-101CL2P-H
3
2"-CLD-011017302-101CH2S-P
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- CONNECTION FOR PIGGING (MECHANICAL DECOKING SYSTEM). SPOOL PIECE REPLACED BY PIGGING ELBOW DURING MAINTENANCE. 2- SPOOL PIECES SHALL BE MINIMUM DISTANCE FROM THE HEATER. 3- OP. TEMP.: 281 TO 366º AND OP. PRESS.: 11.2-2.0 barg. 4- SKIN THERMOCUPLE SUPPLY BY VENDOR. 5- COIL MATERIAL: 5 Cr + 3 mm. 6- SPOOL MATERIAL BY TRJR.
HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
011-F-0001 barg °C barg Gcal/h
11.20 281.00 20.50 84.70
NOTE 5 NOTE 3 NOTE 3
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
5545
6364
05
13-MAR-2013
AB
04
30-SEP-2011
03
2 1
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
TOPPED CRUDE
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / FBL
RDP / MAC
JAL
TO 011-C-0002
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MMG / SGT
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
DATE
UTILITIES IDENTIFICATION POS.
DS011-TRJR-480311
AVS / HCR
DS011-TRJR-480041 3214
GENERAL NOTES
DS011-TRJR-480030
MJR / STG
7687
DS011-TRJR-480030 3233
SIGNAL FROM FC-0014 A
AB: AS BUILT
25
TOPPED CRUDE PASS 2 FROM 011-E-0020
SIGNAL TO FC-0015 B
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY 011-078
PIPING AND INSTRUMENT DIAGRAM Project:
011-074
011-076 011-075 011-080
Item Tags :
011-F-0001
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE HEATER PASS 2 - PROCESS COIL ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480035 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480035 2271-011-PID-0021-017
REV: 05
Sheet: 2 of 9
SCALE: NONE Format:
A1
41
41
011-F-0001 CRUDE HEATER
40
40
39
39
38
38
37
37
36
36
35
35
TRJR
VENDOR
34
34
VENDOR
33
TRJR
33
32
32
31
31
STRIPPING STEAM FROM HEADER
30
SEE DWG. DS011-TRJR-480042 12"
29
TE 0092 C SKIN NOTE 4
0092 C
28
NOTE 1
27
PI 0027 C
26
30 29
H
TI
STRIPPING STEAM TO 011-C-0002
16"
TI
TE
0093 C
0093 C
28
NOTE 4
V
27
NOTE 2
26
25
TI 0094 C
H
25
24
24
23 22
INST. PIPING
21 20
PI
PT
0026 C
0027 C
23
TE 3/4"
3/4"
3/4"
3/4"
PASS 3
22
0094 C SKIN NOTE 4
21 20
6"-CRU-011017403-103CL2P-H
6"-CRU-011017004-103CL2P-H
19
19
18
18
17
TE 0095 C
16
TI 0095 C
H
17
TY
15
TI 0096 C
14
15
TI 0100 C
TE 0096 C SKIN NOTE 4
HH
TC 0097 C
14
H
13
SP 12
11
11
NOTE 1 CL300
10
TT 0100 C
NOTE 2
D 9
TT 0097 C
10 9
14"x6"
8
011-F-0001
2"
2"
NOTE 6
8 7
MIN.
7 6
6
2"
5
MIN.
2"-CRU-011017012-101CL2P-P
2
6"-CRU-011017004-103CL2P-H
1
5
D
4
25
FROM 011-E-0020
TO 011-C-0002
DS011-TRJR-480031 3178
DS011-TRJR-480041 3182
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- CONNECTION FOR PIGGING (MECHANICAL DECOKING SYSTEM). SPOOL PIECE REPLACED BY PIGGING ELBOW DURING MAINTENANCE. 2- SPOOL PIECES SHALL BE MINIMUM DISTANCE FROM THE HEATER. 3- OP. TEMP.: 281 TO 366º AND OP. PRESS.: 11.2-2.0 barg. 4- SKIN THERMOCUPLE SUPPLY BY VENDOR. 5- COIL MATERIAL: 5 Cr + 3 mm 6- SPOOL MATERIAL BY TRJR.
barg °C barg Gcal/h
11.20 281.00 20.50 84.70
NOTE 5 NOTE 3 NOTE 3
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
SIGNAL
SIGNAL
FROM TY-0097 AA
TO TY-0097 AA
FROM FC-0014 A
TO FC-0015C
DS011-TRJR-480034
DS011-TRJR-480034
DS011-TRJR-480311
DS011-TRJR-480031
6338
6337
5493
5497
05
13-MAR-2013
AB
AB : AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / SGT
AVS / MAC
AR
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / SGT
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MMG / SGT
RDP / MAC
JAL
REV
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
2 1
TOPPED CRUDE
TOPPED CRUDE PASS 3
011-F-0001
SIGNAL
2"-CLD-011017303-101CH2S-P
7688
3
SIGNAL
101CL2P 101CH2S
250 mm MIN.
3
MIN. 2"
14"-CRU-011017002-101CL2P-H
4
HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
16
OP
H
13 12
0097 C
ZC 0330
NOTE 4 SKIN
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM Project:
011-074 011-076 011-075 011-080
Item Tags : 011-F-0001
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE HEATER PASS 3 - PROCESS COIL ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480036.pid
Discipline: PRO
SA-JER-DS011-TRJR-480036 2271-011-PID-0021-017
REV:
05
Sheet: 3 of 9
SCALE: NONE Format:
A1
41
41
011-F-0001 CRUDE HEATER
40
40
39
39
38
38
37
37
36
36
35
35
34
TRJR
VENDOR
VENDOR
34
TRJR
33
33
32
STRIPPING STEAM FROM HEADER
SEE DWG. DS011-TRJR-480042 12"
31
32
STRIPPING STEAM 16"
TO 011-C-0002 31
30
30
29
H
TI 0092 D
28
NOTE 1
27
29
TE 0092 D
NOTE 4 SKIN
TI
TE
0093 D
0093 D
V
28
SKIN NOTE 4
27
NOTE 2
26
26
PI
25
25
0027 D TI 0094 D
24
PI 0026 D
23
3/4"
20
24
PT 0027 D
23
22 21
H
3/4"
INST. PIPING
PASS 4
22
TE NOTE 4 0094 D SKIN
21
6"-CRU-011017005-103CL2P-H
20
6"-CRU-011017404-103CL2P-H
19
19
18
18
TY
17
2"
16
TE 0095 D
TI 0095 D
TI 0096 D
14
ZC 0330
OP
17 16
SKIN NOTE 4
15
0097 D
H
H TI
TC 0097 D
HH
0100 D
15
H
14
SP
13
13
TE NOTE 4 0096 D SKIN
12
12
11
11
NOTE 1 CL300
10
TT 0100 D
NOTE 2 D
9
CL300
CL300
2"
011-F-0001
8
2"
7
MIN.
7
10 9
14"x6" NOTE 6
8
TT 0097 D
6
6
2"
5
5
MIN. 2"
2"-CRU-011017013-101CL2P-P MIN.
4
4
D
3
2"-CLD-011017304-101CH2S-P
25 7689
SIGNAL
FROM TY-0097 AA
TO TY-0097 AA
FROM FC-0014 A
TO FC-0015 D
DS011-TRJR-480034
DS011-TRJR-480034
DS011-TRJR-480311
DS011-TRJR-480031
6340
6339
5494
5501
2 1
05
13-MAR-2013
AB
AB : AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / SGT
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / SGT
RDP / MAC
JAL
FROM 011-E-0020
TO 011-C-0002
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MMG / SGT
RDP / MAC
JAL
DS011-TRJR-480031 3187
DS011-TRJR-480041 3188
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- CONNECTION FOR PIGGING (MECHANICAL DECOKING SYSTEM). SPOOL PIECE REPLACED BY PIGGING ELBOW DURING MAINTENANCE. 2- SPOOL PIECES SHALL BE MINIMUM DISTANCE FROM THE HEATER. 3- OP. TEMP.: 281 TO 366º AND OP. PRESS.: 11.2-2.0 barg. 4- SKIN THERMOCOUPLE SUPPLY BY VENDOR. 5- COIL MATERIAL: 5 Cr + 3 mm 6- SPOOL MATERIAL TRJR.
011-F-0001 barg °C barg Gcal/h
SIGNAL
TOPPED CRUDE
TOPPED CRUDE PASS 4
HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
3
SIGNAL
14"-CRU-011017002-101CL2P-H
250 mm MIN.
6"-CRU-011017005-103CL2P-H
2 1
101CL2P 101CH2S
SIGNAL
11.20 281.00 20.50 84.70
NOTE 5 NOTE 3 NOTE 3
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
REV
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM Project:
011-074
011-076 011-075 011-080
Item Tags : 011-F-0001
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE HEATER PASS 4 - PROCESS COIL ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480037.pid
Discipline: PRO
SA-JER-DS011-TRJR-480037 2271-011-PID-0021-017
REV:
05
Sheet: 4 of 9
SCALE: NONE Format:
A1
41
41
40
40
39
39
011-F-0001 CRUDE HEATER
38
38
37
37
36
36
35
35
34
34
SIGNAL
33
TRJR
TO TC-0097 F
VENDOR
VENDOR
6372
TRJR
33
32
32
31
31
STRIPPING STEAM FROM HEADER
30
SEE DWG. DS011-TRJR-480042
29
TI 0092 E
28
NOTE 1
27
H
FROM TC-0097 F
6373
30 29
TE 0092 E
TI
NOTE 4 SKIN
TE
0093 E
28
0093 E SKIN NOTE 4
27
V
NOTE 2
PI 0027 E
26
16"
12"
SIGNAL
STRIPPING STEAM TO 011-C-0002
26
TC H TI 0094 E
25
0097 BA
25
24
24
PI 0026 E
23
PT 0027 E
22
3/4"
3/4"
23
TE
INST. PIPING
21 20
22
NOTE 4 0094 E SKIN
21
6"-CRU-011017006-103CL2P-H
PASS 5
6"-CRU-011017405-103CL2P-H
20
X
TY
19
19
0097 BA 18
18
17
TE 0095 E
16
H TI 0095 E
17
ZC 0330
16
NOTE 4 SKIN
15
TI 0096 E
14
SP
H TI 0100 E
15
H
HH
TC
14
0097 E
13
13
TE NOTE 4 0096 E SKIN
12
12
11
11
NOTE 1 TT 0100 E
CL300
NOTE 2
10
TT 0097 E
10
D 9
9
14"x6" NOTE 6
8
CL300 2"
8
MIN.
011-F-0001
7
CL300 2"
7
2" MIN. 2"
2"-CRU-011017014-101CL2P-P MIN.
4
6"-CRU-011017006-103CL2P-H
2 1
D 4
101CL2P 101CH2S
250 mm MIN.
3
5
25 7691
TOPPED CRUDE PASS 5
TOPPED CRUDE
FROM-011-E-0020
TO 011-C-0002
DS011-TRJR-480032 3191
DS011-TRJR-480041 3192
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- CONNECTION FOR PIGGING (MECHANICAL DECOKING SYSTEM). SPOOL PIECE REPLACED BY PIGGING ELBOW DURING MAINTENANCE. 2- SPOOL PIECES SHALL BE MINIMUM DISTANCE FROM THE HEATER. 3- OP. TEMP.: 281 TO 366º AND OP. PRESS.: 11.2-2.0 barg. 4- SKIN THERMOCOUPLE SUPPLY BY VENDOR. 5- COIL MATERIAL: 5 Cr + 3 mm. 6- SPOOL MATERIAL BY TRJR.
HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
011-F-0001 barg °C barg Gcal/h
11.20 281.00 20.50 84.70
NOTE 5 NOTE 3 NOTE 3
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
SIGNAL
SIGNAL
SIGNAL
SIGNAL
SIGNAL
SIGNAL
FROM TC-0097 H
TO TC-0097 H
FROM FC-0015 E
FROM FC-0015 F
FROM FC-0015 G
FROM FC-0015 H
DS011-TRJR-480041
DS011-TRJR-480041
DS011-TRJR-480032
DS011-TRJR-480032
DS011-TRJR-480033
DS011-TRJR-480033
SIGNAL TO AIR/FUEL SYSTEM DS011-TRJR-480116
6368
6367
5503
5504
5505
5506
6370
14"-CRU-011017002-101CL2P-H
5
6
2"-CLD-011017305-101CH2S-P
6
3 2 1
SIGNAL
SIGNAL
SIGNAL
TO TY-0097 E
FROM TC-0097 G
TO TC-0097 G
DS011-TRJR-480311
DS011-TRJR-480040
DS011-TRJR-480040
6365
6366
6369
05
13-MAR-2013
AB
AB : AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / SGT
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / SGT
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MMG / SGT
RDP / MAC
JAL
REV
DATE
UTILITIES IDENTIFICATION POS.
DESCRIPTION
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
FIRE WATER SERVICE WATER 011-073 COOLING WATER 011-072 POTABLE WATER 011-073 011-071 DEMI WATER N.A. N.A. N.A. HP STEAM 011-071 MP STEAM 011-071 LP STEAM HP CONDENSATE MP CONDENSATE 011-071 LP CONDENSATE 011-071 BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS. 19 20 21 22 23 24 25 26 27 28 29 30 31 32
011-071 011-074 011-074
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 011-075
Item Tags : 011-F-0001
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE HEATER PASS 5 - PROCESS COIL ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480038 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480038 2271-011-PID-0021-017
REV: 05
Sheet: 5 of 9
SCALE: NONE Format:
A1
41
41
011-F-0001 CRUDE HEATER
40
40
39
39
38
38
37
37
36
36
35
35
34 33
34
SIGNAL 6372FROM TY-0097 BA
33
32
32
31
31 6373 SIGNAL
30
30
TO TY-0097 BA
29
29
28
28
27
27
26
26
STRIPPING STEAM FROM HEADER
25
STRIPPING STEAM TO 011-C-0002
SEE DWG. DS011-TRJR-480042 16"
12"
25
24
24
H TI 0092 F
23 22
NOTE 1
PI 0027 F
21
TE NOTE 4 0092 F SKIN
TI
TE
0093 F
0093 F
23
SKIN NOTE 4
22
V
NOTE 2
21
20
TI
20
H
0094 F
19
PI 0026 F
18 17
INST. PIPING
16
3/4"
19
PT 0027 F
INST. PIPING
18 17
TE NOTE 4 0094 F SKIN
3/4"
16
15
15
6"-CRU-011017007-103CL2P-H
PASS 6
6"-CRU-011017406-103CL2P-H
14
14
VENDOR
TRJR
13
13
12
TRJR
11
TE 0095 F
VENDOR
H TI 0095 F
12
ZC 0330
11
NOTE 4 SKIN
10
TI 9
10
H
SP
0096 F
TI
H
HH
0100 F
8
TE 0096 F
7
TC
TY
0097 F
0097 F
9
OP
8 7
NOTE 4 SKIN
6
6
NOTE 1 CL300
5
5
NOTE 2 D
4
14"x6" NOTE 6
011-F-0001
3
CL300 2"
6"-CRU-011017007-103CL2P-H
MIN. 250 mm MIN.
D 101CL2P 101CH2S
NOTES 1- CONNECTION FOR PIGGING (MECHANICAL DECOKING SYSTEM). SPOOL PIECE REPLACED BY PIGGING ELBOW DURING MAINTENANCE. 2- SPOOL PIECES SHALL BE MINIMUM DISTANCE FROM THE HEATER. 3- OP. TEMP.: 281 TO 366º AND OP. PRESS.: 11.2-2.0 barg. 4- SKIN THERMOCOUPLE SUPPLY BY VENDOR. 5- COIL MATERIAL: 5 Cr + 3 mm. 6- SPOOL MATERIAL BY TRJR.
NOTE 5 NOTE 3 NOTE 3
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
TO 011-C-0002 DS011-TRJR-480041 3201
7692
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
11.20 281.00 20.50 84.70
TOPPED CRUDE
2"-CLD-011017306-101CH2S-P 25
GENERAL NOTES
barg °C barg Gcal/h
MIN. 2"
2"-CRU-011017015-101CL2P-P
FROM 011-E-0020 DS011-TRJR-480032 3197
011-F-0001
SIGNAL
2"
TOPPED CRUDE PASS 6
HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
CL300 2"
MIN.
2 1
4
14"-CRU-011017002-101CL2P-H
3
TT 0097 F
TT 0100 F
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
FROM FC-0014 B
TO FC-0015 F
DS011-TRJR-480311
DS011-TRJR-480032
5515
4070
2 1
05
13-MAR-2013
AB
AB : AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV/ STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / SGT
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MMG / SGT
RDP / MAC
JAL
REV
DATE
UTILITIES IDENTIFICATION POS.
SIGNAL
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE HEATER PASS 6 - PROCESS COIL ORIGINAL SIGNED IN PROJECT FILE
Item Tags : 011-F-0001
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480039 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480039 2271-011-PID-0021-017
REV: 05
Sheet: 6 of 9
SCALE: NONE Format:
A1
41
41
011-F-0001 CRUDE HEATER
40
40
39
39
38
38
37
37
36
36
35
35
34
34
33
33
TRJR
VENDOR
VENDOR
TRJR
32
32
31
31
30
30
STRIPPING STEAM FROM HEADER
29
16"
12"
28
H
TI
TE
0092 G
27
NOTE 1
26
PI
STRIPPING STEAM TO 011-C-0002
SEE DWG. DS011-TRJR-480042
0092 G
29 28
TI 0093 G
NOTE 4 SKIN
TE NOTE 4 0093 G SKIN
27
V
26
NOTE 2
0027 G
25
25
24
TI
H
24
0094 G PI 0026 G
23
PT 0027 G
23
22
22
21
INST. PIPING 3/4"
3/4"
20
3/4"
3/4"
19
PASS 7
TE 0094 G
21
NOTE 4 SKIN
20
6"-CRU-011017008-103CL2P-H
19
6"-CRU-011017407-103CL2P-H
18
TY
18
OP
0097 G
17 16 15
TE
TI
0095 G
0095 G
H
16
ZC
NOTE 4 SKIN
15
0330 H TI 0096 G
14
14
13
TC 0097 G
HH
TI
H 13
SP
0100 G
12
17
12
TE
NOTE 4 0096 G SKIN
11
11
NOTE 1
10
TT 0100 G
CL300
NOTE 2
9
10
TT 0097 G
9
D 14"x6" NOTE 6
8
8
2" CL300
2" CL300
011-F-0001
TOPPED CRUDE TO 011-C-0002 4155
14"-CRU-011017002-101CL2P-H MIN.
7 6
6
2"
5 4
5
MIN. 2"
2"-CRU-011017016-101CL2P-P
2
SIGNAL
SIGNAL
SIGNAL
SIGNAL
FROM TY-0097 BA
TO TY-0097 BA
FROM FC-0014 B
TO FC-0015 G
DS011-TRJR-480038
DS011-TRJR-480038
DS011-TRJR-480311
DS011-TRJR-480033
6369
6366
5516
4073
101CL2P 101CH2S
250mm MIN.
1
4
D
MIN.
3
7
3 2 1
2"-CLD-011017307-101CH2S-P
25 7697
TOPPED CRUDE PASS 7 FROM 011-E-0020 DS011-TRJR-480033 3204
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- CONNECTION FOR PIGGING (MECHANICAL DECOKING SYSTEM). SPOOL PIECE REPLACED BY PIGGING ELBOW DURING MAINTENANCE. 2- SPOOL PIECES SHALL BE MINIMUM DISTANCE FROM THE HEATER. 3- OP. TEMP.: 281 TO 366º AND OP. PRESS.: 11.2-20. barg. 4- SKIN THERMOCOUPLE SUPPLY BY VENDOR. 5- COIL MATERIAL: 5 Cr + 3 mm 6- SPOOL MATERIAL BY TRJR.
HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
011-F-0001 barg °C barg Gcal/h
NOTE 5 11.20 NOTE 3 281.00 NOTE 3 20.50 84.70
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
AB : AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / SGT
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / SGT
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
VJS / SGT
RDP / MAC
JAL
REV
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE HEATER PASS 7 - PROCESS COIL ORIGINAL SIGNED IN PROJECT FILE
Item Tags : 011-F-0001
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480040 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480040 2271-011-PID-0021-017
REV: 05
Sheet: 7 of 9
SCALE: NONE Format:
A1
41
41
011-F-0001 CRUDE HEATER
40
40
39
39
38
TRJR
VENDOR
VENDOR
38
TRJR
37
37
36"-CRU-011017002-101CL2P-H STRIPPING STEAM FROM HEADER
36
STRIPPING STEAM TO 011-C-0002
SEE DWG. DS011-TRJR-480042 16"
12"
36
35
35
34
TI
H
0092 H
33
NOTE 2
PI
32
0027 H
34
TE
TI 0093 H
0092 H NOTE 8 SKIN
TE 0093 H
33
NOTE 8 SKIN
V
32
NOTE 3
31
31
30
30
PI 0026 H
29
PT 0027 H
28
3/4"
29
INST. PIPING
3/4"
27
H TI 0094 H
28
TE 0094 H
NOTE 8 SKIN
27
26
26
PASS 8
6"-CRU-011017009-103CL2P-H
6"-CRU-011017408-103CL2P-H
25
25
24
24
23
23
22
TE 0095 H
H TI 0095 H
21
NOTE 8 SKIN
H
20
22
ZC 0330
TI 0096 H
21 20
TI
19
H
HH
TC 0097 H
0100 H TE
18
0096 H
19
SP
18
NOTE 8 SKIN
17
17
NOTE 2
TT 0100 H
CL300
16
NOTE 3
TT 0097 H
16
D
15
15
14"x6"
CL300 2"
CL300 2"
NOTE 9
14
14
14"-CRU-011017002-101CL2P-H
12
2" MIN.
2"-CRU-011017017-101CL2P-P
2"
250mm MIN. MIN.
8
NOTE 4
CL300 2" NOTE 1
11 10 9
0.2%
101CL2P 101CH2S
8
2"-CLD-011017308-101CH2S-P 14"-CRU-011017002-101CL2P-H
6
14"-CRU-011017002-101CL2P-H
TOPPED CRUDE 4155FROM 011-F-0001
12
D
25
7
L
TT 0098
7695
5
TY 4
0097 H
OP
36"-CRU-011017002-101CL2P-H
9
H
14"-CRU-011017002-101CL2P-H
10
TI 0098
7 6
NOTE 5
011-F-0001
11
13
MIN.
13
5 4
1
TOPPED CRUDE PASS 8 FROM 011-E-0020 DS011-TRJR-480033 3209
SIGNAL
SIGNAL
SIGNAL
SIGNAL
FROM FC-0014 B
TO FC-0015 H
TO TY-0097 BA
FROM TY-0097 BA
DS011-TRJR-480311
DS011-TRJR-480033
DS011-TRJR-480038
DS011-TRJR-480038
5517
4074
6368
6367
14"-CRU-011017002-101CL2P-H
6"-CRU-011017009-103CL2P-H
14"-CRU-011017002-101CL2P-H
2
14"-CRU-011017002-101CL2P-H
3
14"-CRU-011017002-101CL2P-H
3
TOPPED CRUDE
TOPPED CRUDE
TOPPED CRUDE
TOPPED CRUDE
FROM PASS 1
FROM PASS 2
FROM PASS 3
FROM PASS 4
DS011-TRJR-480034 3213
DS011-TRJR-480035 3214
DS011-TRJR-480036 3182
DS011-TRJR-480037 3188
TOPPED CRUDE
TOPPED CRUDE
TOPPED CRUDE
FROM PASS 5
FROM PASS 6
TO 011-C-0002
DS011-TRJR-480038 3192
DS011-TRJR-480039 3201
DS011-TRJR-480044 3216
05
13-MAR-2013
AB
04
30-SEP-2011
03
GENERAL NOTES
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / SGT
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
VJS / SGT
RDP / MAC
JAL
HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
011-F-0001 barg °C barg Gcal/h
11.20 281.00 20.50 84.70
NOTE 7 NOTE 6 NOTE 6
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
1
AB : AS BUILT
REV
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER NOTES 4 POTABLE WATER 5 DEMI WATER 1- AVERAGE TEMPERATURE TO BE CALCULATED FROM OUTLET TEMPERATURE OF EACH PASS AND MASS FLOW RATE PER PASS. 6 N.A. 2- CONNECTION FOR PIGGING (MECHANICAL DECOKING SYSTEM). 7 N.A. 3- SPOOL PIECES SHALL BE MINIMUM DISTANCE FROM THE HEATER. 8 N.A. 4- DEVIATION ALARM TO ALERT OPERATOR IN CASE OF SIGNIFICANT CHANGE IN TEMPERATURE FROM PREVALING TEMPERATURE PROFILE 5- FOR 36" LINE USE 90º ELBOWS R=5D. 9 HP STEAM 6- OP. TEMP.: 281 TO 366º AND OP. PRESS.: 11.2-2.0 barg. 10 MP STEAM 7- COIL MATERIAL: 5 Cr + 3 mm 11 LP STEAM 8- SKIN THERMOCOUPLE SUPPLY BY VENDOR. 12 HP CONDENSATE 9- SPOOL MATERIAL BY TRJR. 13 MP CONDENSATE 14 LP CONDENSATE 15 BFW 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A.
2
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM Project:
011-074
011-076 011-075 011-080
Item Tags : 011-F-0001
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE HEATER PASS 8 - PROCESS COIL ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480041 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480041 2271-011-PID-0021-017
REV: 05
Sheet: 8 of 9
SCALE: NONE Format:
A1
8"x6" 8"-LPS-011017003-101CJ1P-P NOTE 5 CL300 101CJ1P 103CJ1P NC
38 37 36
8"x6" 8"-LPS-011017002-101CJ1P-P NOTE 5 CL300 101CJ1P 103CJ1P NC
3/4" V
35
LC FB
34
LC FB
2"
LO FB LO FB
NOTE 10 2"
ES
6"x4"
H
30
TT 29
NOTE 20
0091 VENDOR
28
11
ZHSR
0395
0320
0024
ZHXS
ZC
0024 L
0371
ZC
0024
0395
V PIPING INST.
ZYC
ZLO
ZLC
0096
0096
0096
0096
ZHS
ZY
ZLS
ZLS
0096
0096
0096 O
0096 C
101CS1P 101CJ1P
RO 0026 +
FO TSO
ZC
ZC
0395
0371
ZV 0024
CLOSED
3/4"
OPEN
ZLS
0024
0024 C
ZLO
ZLS
0024
0024 O
ZHA
011-DS-0001 16"-LPS-011017015-103CJ1P-H
0024
BY-PASS
16" CL300
OLW
6"-LPS-011017012-101CJ1P-H 3/4"
0024
D
INST. PIPING
FV 0021 +
CL600 2"
12" 18"x12"
16"-LPS-011017011-101CJ1P-H 2"
CL300
NOTE 21
NOTE 15
CL300
TI 0359
L
FT 0021
TT 0360
2190
1-1/2"
FC 0021
TI 0360 LL
ZHS
1"-OLW-011017302-101CS1P-P
FMC
25
16"x12" FC 3/4" D TSO CL300
TI
TT
0358
0359
36
ZYV 0096 +
2"
TC 0043
24
1"-BFW-011017002-103CJ1P-H
H
TT 0043
34
IA DE
33
ATM BY-PASS
POSITIONER OPEN
ZHA 0091
ZYC 0091
ATM CLOSED
32
ZLC 0091
31
ZLO 0091
30
ZHS 0091
ZY 0091
ZLS 0091 O
29
ZLS 0091 C
ZV 0091
LPT
+
MIN.
27
FC TSO
3/4" D
28
+
ZV 0096 FC TSO NOTE 14
26 25
16"x10" 10" 18"x10"
1-1/2"x1"
35
+
DE
NC
CL300 2"
ZYV 0091
S
IA
OLW
CL300
38
ZC 0371
S
011-Y-0004
39
ZHXS ES 0091
37
NOTES 17
NOTE 1, 2 ZLC
ZHXS 0091 L NOTE 12
0320
+
D
NOTE 16
ZHSR 0091
+
MFR. PIPING.
16"
RESET
ZC
DE
PIPING MFR.
ZC 0320
1"-OLW-011017002-101CS1P-P 10"x6"
ZYV 0024
S
ATM
12"-LPS-011017301-101CS1P-H
ZHA
ZC 0395
ES ZHXS
40
CLOSED
011-Y-0003
10"-LPS-011017014-101CS1P-P
3/4"
CL300 2"
27
ZC
1"-IAI-011017301-301CG2P-N
0024 A NOTE 18 1"-IAI-011220310-301CG2P-N
6"-LPS-011017010-103CJ1P-H
TI 0091
31
ZC
NOTE 12
ZPI
7756
32
26
+
17
6"-LPS-011017010-103CJ1P-H
TRJR
ZPZV 0024
V NOTE 10 011-SP-0024
33
RESET
3/4"
3/4"
BY-PASS POSITIONER OPEN
NOTE 1 ATM
+
+
6"x4"
3/4"
1/2" 3/4" 12.00
PZV 0009
101CS1P
+
INSULATION: H
MIN.
+
41
011-Y-0004 011-C-0002 LP STEAM STRIPPING STEAM SILENCER
101CJ1P
PZV 0010
39
4"M6" 7.00
NOTE 2 ATM
011-Y-0003 011-F-0001 LP STEAM SUPERHEATED SILENCER
1/2"
+
011-DS-0001 011-F-0001 LP STEAM DESUPERHEATER
1/2"
4"M6" 7.00
NOTE 2 ATM
40
011-F-0001 CRUDE HEATER
4"-LPS-011017008-101CS1P-H
41
1-1/2"-LPS-011017008-101CS1P-H 24
NC
12"
23
23
21
SEE DWGS. FROM DS011-TRJR-480034 TO DS011-TRJR-480041
TOPPED CRUDE FROM 011-E-0020
103CJ1P 101CS1P
22
ST
TOPPED CRUDE TO 011-C-0002
TV 0043 +
22
1"-BFW-011017301-101CS1P-H
1"
21
15
20
CL300 3/4" D FLC 3/4" D
19
1"
6378
D
3/4"
3/4"
D
3/4"
D
20 19
3/4"
18
18
NC
RO 0070 +
17
17 16
16 15
15
OLW
8"-LPS-011017005-101CJ1P-H 14
14
8"x6"
13
13
12
12
11
11
10
10
VENDOR
9
TRJR
9 8
18"-LPS-011017001-101CS1P-H
8 7 6 5 4
7 6 5 4
011-F-0001
3
3
STRIPPING STEAM TO 011-C-0002
1
STRIPPING STEAM TO 011-C-0005 DS011-TRJR-480054 3221
DS011-TRJR-480044 3227
8"-LPS-011017006-101CJ1P-H
6"-LPS-011017005-101CJ1P-H
2
1
STRIPPING STEAM TO 011-C-0006 DS011-TRJR-480056 3224
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALLBE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES
HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
011-DS-0001 VAD 24800.0 3.50 412.00 °C 350.00 °C 7.00 / FV 440.00 011-F-0001
barg °C barg Gcal/h
5 Cr + 3 mm NOTE 8 11.20 NOTE 8 281.00 20.50 84.70
SILENCER TYPE FLOW OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP. SILENCER TYPE FLOW OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP.
Kg/hr barg °C barg °C
Kg/hr barg °C barg °C
011-Y-0004 DIFFUSER+ABSORP. 1000.0 ATM NOTE 19 350.00 3.50 386.00 011-Y-0003 DIFFUSER+ABSORP. 4960.0 1.70 350.00 3.50 386.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
06
13-MAR-2013
AB
AB : AS BUILT
MJR / STG
AVS / HCR
JAL
05
06-OCT-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
VJS / FCB
RDP / MAC
JAL
PREPARED BY
CHECKED BY
APPR/AUTH BY
REV
GENERAL NOTES
DESUPERHEATERS TYPE INLET STEAM kg/h OP. PRESS. barg OP. TEMP. °C in/out DES. PRESS. barg DES. TEMP. °C
2
3, 4, 6, 7, 11, 13 DELETED. 1- AT SAFE LOCATION. INCLUDES ANTIBIRDS MESH. 2- TO ATMOSPHERE AT SAFE LOCATION. 5- PROVIDE WEEP HOLE ø = 10 mm AT LOW POINT. 8- HEATER 011-F-0001: OP TEMP: 281 TO 366ºC AND OP. PRESS: 11.2-2.0 barg. 9- DRUM 011-D-0023: OP. TEMP: 129-350ºC. 10- MECHANICAL LINK. 12- LOCAL EMERGENCY SWITCH BEHIND FIREWALL OR AT SAFE LOCATION. 14- ZV-0091 LOCATED AT MINIMUM DISTANCE FROM 011-C-0002. 15- MINIMUM DISTANCE REQUIRED TO TEMP. SENSOR (TT-0043) 10m. 16- REQUIRED 2m OF STRAIGHT LENGTH PIPE UPSTREAM 011-DS-0001 AND 5m DOWNSTREAM. 17- COMMON RESET SHALL BE CONFIGURATED IN SIL3 VALVE. 18- AIR VESSEL TO ALLOW 3 FULL STROKES CAPACITIES. AND SHALL BE LOCATED OUTSIDE THE FIRE HAZARDOUS AREA. 19- MAXIMUM OP. PRESSURE: 1.60 barg 20- FIRE-PROOFING ACCORDING TO JERERMS-J-4717. 21- MINIMUM DISTANCE POSSIBLE TO AVOID CONDENSATION.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
REF. DWG
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE HEATER-STEAM COIL
Project:
011-074 011-076 011-075 011-080
Item Tags :
011-F-0001
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
011-Y-0003
011-Y-0004
011-DS-0001
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480042.pid
Discipline: PRO
SA-JER-DS011-TRJR-480042 2271-011-PID-0021-017
REV:
06
Sheet: 9 of 9
SCALE: NONE Format:
A1
41 29
0.2%
NOTE 5
2037
8"T10" 14" 3.68 NOTE 14 PZV V NOTE 13 3/4" 3/4" 0046 G FB 14"x10" LO
39
8"T10" 3.68
+
14" NOTE 13 FB LO
38 37
PZV 0046 F
V 14"x10" CL300
CL300
V
3/4"
V
V
CL300 14"x8"
V
NOTE 12
NOTE 14 PZV 0046 C
3/4"
NOTE 13 3/4" V FB LO 14"x10"
3/4"
NOTE 13 3/4" FB LO
+
14"x10"
14"x8"
38
0033
PZV 0047 +
37
14"x8"
3/4"
V
3/4"
TI 0245
TC 0101
35
NOTE 9
H
34
33
33
CORROSION 101CH2S 101CH2F
NOTE 13 LO FB
101CH2S 101CH2F
NOTE 13 LO FB
NOTE 12
NOTE 13 LO FB
101CH2S 101CH2F
101CH2S 101CH2F
NOTE 13 LO FB
NOTE 12
AT
NOTE 13 LC FB 32"-NAP-011018002-101CH2S-P
30
3/4"-LFL-011018301-101CH2F-N CLOSED STRIPPING STEAM OPEN ZC FG ZV VALVES 0320 ZC
HPT
26
101CH2F 101CS1P
40"
NC
M9
0029 C
FV 0019
PT
3/4"
57
3/4"
49
12" A11B
16"x12" 18
16"-JET-011004001-101CS1P-H
M8
15
FC 14
LC
0018
0010
H LG 0011
L
MAG
2"
FT
0010
1/2"
+
6" 8"x6"
8
KEROSENE REFLUX
DS011-TRJR-480008 2870
DS011-TRJR-480063 3237
1/2"
1/2"
FV 0023
0023
+
MIN. 3/4" D 2"x3/4"
101CS1P 101CH2S
16"x12"
TT 0112
2"
25 5040
SIGNAL TO TC-0112
FROM 011-G-0008
LAGO PA FROM B.L.
DS011-TRJR-480018
DS011-TRJR-480140 3240
3982
12"
16"x12"
103CS1P 101CS1P
FC
L11B
2"
NC
MIN.
D 2"x3/4"
103CS1P 101CH2S
25 5041
2"x3/4"
101CS1P 101CH2S
3/4"
ID 24"
3/4" D
2" 3"
DETAIL "A"
4"
INST. PIPING 2"
3 m MIN.
FLOW C L
60º
C L
4 mm
DETAIL "C" COLUMN TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
mm mm barg °C barg °C
011-C-0002 VERTICAL 60950.0 7800.0 1.00 119.00 3.50 200.00
1"
1" 1" 3"
FLOW
NOTE 4
C L
60º
NOTE 8 2 mm
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
CL
101SC1P 101CH2S
LI 0012
T5
2" A8B
ZYC
ZHA
0077
0077
0077
0077
ZLS 0077 O
ZY 0077
ZHS 0077
+
TT 0105
TI
TT 0103
0122
ZLO
ZLS
0122
0122 O
ZY
0123
0123
OPEN ZLO
ZLS
0123
0123 O
21 20 19 18
CLOSED
ZLS 0122 C
17
ZLC
ZLS
0123
0123 C
16
IA
ZC 0419
NOTE 15
15
2" CL300
TI 0105
A9
14"
ATM
ZC 0419
DE
14
ZYV 0123
DE
FO TSO
+
ZYV 0122 RESET
FO TSO
+
3/4"
ZV 0122 +
ZHSR 0122
D
RESET
13 12
ZV 0123 +
ZHSR 0123
11 10
101CH2S 101CS1P
5042
0103
0122
ZYC
22
IA
FC TSO NOTE 2
TI 0104
ZY
ZLC 0122
2"x1"
25
TT 0104
ZYC
ZHS 0123
POSITIONER
CLOSED
3/4"
D 2"x3/4"
OPEN POSITIONER BY-PASS ZLO
ZLS 0077 C
ATM ZV 0077
LL
35
ID 24" 34
9
LO
NAPHTHA
NEUTRALIZING AGENT
FROM 011-G-0005
FROM 011-X-0004
DS011-TRJR-480047 3251
DS011-TRJR-480126 3252
NAPHTHA
8
27
7 6 5 4 3
8261
CORROSION INHIBITOR FROM 011-X-0005
NAPHTHA TO 011-E-0003
2
DS011-TRJR-480127 3132
DS011-TRJR-480004 2797
1
FROM 011-G-0005
4"-DIE-011018003-101CS1P-P 3/4" D
4"-FLO-011018302-101CS1P-N
DS011-TRJR-480135 3231
LAGO VAPOR FROM 011-C-0005
FLO
DS011-TRJR-480054 3245
6159
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES
3"
+
FROM B.L.
25
0349
L11A 2" 1/4" D
T6
16"x12" 12"
WILD NAPHTHA
6859
ZC
ZLC
S
24" 28"x24" NOTE 1 2"
GENERAL NOTES
DETAIL "B"
ZYV 0077
28"-JET-011018001-101CS1P-H
43
A8A
D 3/4"
0077
ZHS 0122
OPEN
MIN.
IA LT 28"x24" 0012
L13A
12"
101CS1P 103CH2S
ZC 0349
24"
44
M6
14"x10" 10" 14"x10"
0310
CLOSED
2"
B5B
M7
3/4" D
3/4" D
DE
B5A
16"x12"
ZHSR
RESET
ZHA 0123
POSITIONER
NC
ZC
PUMP STOP
1/4" D
FO
2"-CLD-011018315-101CH2S-P
KEROSENE PA FROM 011-E-0007
INST. PIPING
0023
MIN.
8"-JET-011026002-101CS1P-H
16"-JET-011004001-101CS1P-H
2
FT
250mm MIN.
2"-CLD-011018308-101CH2S-P
3
NC
MIN.
4
6"x4"
2"-CLD-011018301-101CH2S-P
5
4"
3/4"-DIE-011018004-103CS1P-P
6
2"
A10
INST. PIPING 3/4"
16"-DIE-011098001-103CS1P-H
3/4"-JET-011018002-101CS1P-P
6"x4"
7
L12B
16"-DIE-011018003-101CS1P-H
FC CL300
3"-NAP-011098001-103CH2S-P MIN.
MIN.
CL300
2"
8"
8"-JET-011026002-101CS1P-H
3/4"-JET-011018003-101CS1P-P
8"x6"
9
L13B
L12A
ZHA 0122
6"x4"
45
2" MIN.
10
MIN.
1/2"
D 1/4"
FV 0018
250mm MIN.
INST. PIPING
11
ES
ZHXS
2"
2" 2"
0018
12
16"
D 1/4"
LT
13
48
0077 L
2"
ES
ZHXS 0077
4"
CL300
16"-JET-011022002-101CS1P-H NO POCKET NOTE 6
PIPING INST.
MIN.
16
12"
A11A
6"x4"
TI 0102
BY-PASS
3/4"-NAP-011018003-101CH2S-P A12
INST. PIPING
3/4"
PIPING INST.
TT 0102
24" ID
16"x12" 17
2"
23
+
6"-NAP-011019007-101CH2S-P
3/4"-JET-011018301-101CS1P-P
T7
3/4"
PI 0028
V
19
24
RO 0074
6"x4"
FO CL300
6"
0029 A 20
8"x4"
1/2"
1/2"
BY-PASS
3, 11 DELETED. 1- PROVIDE MINIMUM VERTICAL RUN OF 3 METERS FROM DRAW OFF NOZZLE BEFORE REDUCING THE SIZE LINE. SEE DETAIL "A". 2- INSTALL ZV VALVE MINIMUM DISTANCE FROM 011-C-0002 NOZZLE. 4- OP. TEMP. ºC TOP/BOTTOM: 119 / 354. OP. PRESS (barg) TOP / BOTTOM:1.0 / 1.6. 5- CONNECTION ON TOP OF PIPE. 6- LOCAL EMERGENCY HAND SWITCH BEHIND FIREWALL OR SAFE LOCATION. 7- FOR NOZZLES DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING. 8- DES. TEMP. °C TOP / BOTTOM : 200 / 390 9- CORROSION MONITORING SYSTEM. 10- INJECTION CONNECTION AFTER HIGH POINT OF THE LINE. 12- MECHANICAL LINK. 13- BLOCK VALVE SHALL BE INSTALLED WITH THE STEM IN OR BELOW THE HORIZONTAL POSITION. 14- PZV-0046A/B/C/D/E/F 0047 HAVE BEEN CALCULATED TAKING INTO ACCOUNT CV RATED OF FV-0021 (CV = 1272) AND ITS BYPASS (CV = 1260). 15- QUILL FOR MIXING IMPROVEMENT IS INCLUDED.
28"-JET-011018001-101CS1P-H
21
PT 0029 B
4"
6"x4"
6"-NAP-011019007-101CH2S-P
A13
14"-DIE-011023002-101CS2P-H NO POCKET
22
25
+
23
3/4"
INST. PIPING
NOTE 7 24" ID
32"-NAP-011018002-101CH2S-P
FT 0019
FC 0019
011-C-0002
B6
3/4"
PT
6" V
101CH2S 101SC1P
LL
25 24
28
3"-NAP-011019008-101CH2S-P
PI 0029
MIN.
L
PY 0029
29
27
250mm MIN.
NOTE 5
PI 0029 D
2oo3
MIN.
2071
26
2oo3
103CH2S 101CH2S
HH
2"-CLD-011018306-101CH2S-P
H
30
2"-NAP-011018004-103CH2S-P
8"-NAP-011018005-101CH2S-P
0419
3/4"-LFL-011018302-101CH2F-N
INST. PIPING
CL300 2"
101CH2S 101SC1P
16"-JET-011022002-101CS1P-H
29
SEE DETAIL "C" SEE DETAIL "B"
INST. PIPING
27
CL300 2"
31
4"-N2L-011018301-101CS1P-N
ZC 0330
0245
S
ZC 0371
0101
2"-CHP-011054002-101SC1P-N
ZC 0377
TT
NO POCKET
40"-NAP-011018001-101CH2S-P
2"-CHP-011054702-101SC1P-N
28
ZC 0378
NOTE 10
NOTE 10
TT
CL300 2"
3"-NAP-011019008-101CH2S-P
29
32
0033
40"-NAP-011018001-101CH2S-P
31
101CH2S 101CH2F
NOTE 13 LO FB
4"-NAP-011018005-101CH2S-P
FB LO NOTE 13
101CH2S 101CH2F
NOTE 13 LO FB
ATM
101CH2S 101CH2F
101CH2S 101CH2F
32
1
36
CMS
AI 0033
V
NOTE 12
3/4"
3/4"
3/4"
14"x8"
3/4"
V
AI
CL300
CL300
3/4" NOTE 12
NOTE 13 3/4" V FB 14"x10" LO
+
CL300 14"x8"
+
PZV 0046 A
V
39
8"T10" 3.50
NOTE 14
PZV 0046 B
40
TRIM: NAP-011018601-101CH2S / JET-011018601-103CS1P INSULATION: H
14"
+
NOTE 14
+
V
011-SP-0025
8"T10" 3.50
14"
+
CL300
3/4"
3/4"
3/4"
NOTE 13 FB 3/4" V LO 14"x10"
+
14"x8"
3/4" NOTE 12
3/4"
34
+
14"x8"
3/4" 35
NOTE 14
8"T10" 3.68
14"
+
PZV 0046 D
NOTE 13 FB 3/4" V LO 14"x10"
CL300
14"x8"
8"T10" 3.68
14"
+
NOTE 14
PZV 0046 E
NOTE 13 3/4" V FB 14"x10" LO
+
8"T10" 3.68
14"
+
NOTE 14
+
36
8"T10" 3.68
14"
+
42"-LFL-011018301-101CH2F-N
S
40
41
011-C-0002 ATMOSPHERIC COLUMN
KEROSENE TO 011-C-0004 & 011-G-0008 DS011-TRJR-480052 3247
DS011-TRJR-480047 3249
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
AVS / MAC
JAL
KEROSENE VAPOR
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / FCB
RDP / MAC
JAL
FROM 011-C-0004
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MMG / STG
RDP / MAC
JAL
DS011-TRJR-480052 3248
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080 011-077
011-C-0002
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE DISTILLATION COLUMN ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480043.pid
Discipline: PRO
SA-JER-DS011-TRJR-480043 2271-011-PID-0021-018
REV:
05
Sheet: 1 of 2
SCALE: NONE Format:
A1
011-C-0002 2" 2"
+
8"x6" 6"
33
D
MIN.
LC
0022
0016
MIN.
H
10" A5B
3/4"-HFO-011018007-101CL2P-P
LG 0017
0022
1/2" 1/2"
1/2"
3/4" D FV 0022
1/2"
NC PIPING
2"x3/4"
20
6" 10"x6"
16
FC
2"-CLD-011018304-101CH2S-P
L7B L6B
L5B
2"
2"
2"
2"
L6A
15
L7A
2"
103CL2P 101CH2S
7
11 10 9
1" PIPING INST. 1"x3/4"
M2
LI 0125
LG 0019
2" 2" 2"
2" 1/4"
LT 0125 LT
1"x3/4" INST. PIPING 1"
8
NC
LI
5
2"
0020 L
ID 24"
LC 0020
3/4"
2"
PT 2"
2" PIPING
2" L1B
HAGO PA
TOPPED CRUDE
STRIPPING STEAM
FROM 011-E-0017
FROM 011-G-0012
FROM 011-F-0001
FROM 011-F-0001
DS011-TRJR-480064 3262
DS011-TRJR-480026 3190
DS011-TRJR-480065 3268
DS011-TRJR-480041 3216
DS011-TRJR-480042 3227
OPEN POSITIONER BY-PASS ZLO 0079
ZYC 0079
27
ZHA 0079
26
TT 0109
ES
0079 ATM
ZLS 0079 C
ZLS 0079 O
ZY 0079
ZHS 0079
25 24
2" CL300
22 21
2"-FLO-011018301-101CS1P-N
1" D
0030
FLO
20
5409
19
MIN.
18
TT 0111
TI 0111
17
8"-CRU-011018001-101CL4P-H
2"
INST.
FI 0117
CLOSE STEAM INJECTION
2" LT
LI
0124
0124
16
1/2" 1/2"
ZC 0340
15
FT 0117
CL300 14
1/2" 1/2" ZC 0371
INST.
HH
ZC 0342
LL
13
PIPING
PUMP STOP
12 11
0021 L
2" 2"
8" A14 L1A 2"
ID 24"
M1
2"
2"
ZHXS
2"
ES
0006 L 1/4"
LT 0021
ZC
ZHXS
0302
0006
NUCL.
ZYV 0006
B1 20"
ES
RESET
NOTE 3 +
ZHSR 0006
S
DE
ZV 0006
MIN.
1"
IA.
NC
+
L
ATM
6"
6"-HFO-011018105-103CL4P-S
2"
TT 0113
103CL4P 101CS1P 103CL4P 101CH2S
FC TSO
6"-OLW-011018301-101CS1P-N TI 0113
SIGNAL TO FC-0033-A
DS011-TRJR-480312
OLW
4178 SIGNAL
SIGNAL TO HS-0053-A
TO FC-0033-B
25
DS011-TRJR-480104
DS011-TRJR-480312
3020
4171
6136
10, DELETED. 1- LIQUID DRAW THROUGH TWO NOZZLES LOCATED AT 180º. PROVIDE MINIMUM VERTICAL RUN OF THE HIGHEST OF 3 METERS FROM NOZZLE, AT NOZZLE SIZE, SEE DETAIL "A". 2- INSTALL ZV VALVE MINIMUM DISTANCE FROM 011-C-0002 NOZZLE. 3- LOCAL EMERGENCY SWITCH BEHIND FIREWALL OR IN SAFE LOCATION. 4- ENSURE THAT NOZZLES FOR LEVEL TRANSMITTERS ARE AT THE SAME ELEVATION. 6- OP. TEMP.ºC TOP / BOTTOM: 119 / 354. OP. PRESS (barg) TOP/BOTTOM: 1.0/1.6. 7- MAKE CONNECTION ON TOP OF LINE. 8- DES. TEMP. ºC TOP/BOTTOM: 200/390. 9- FOR NOZZLES DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING. 11- CHECK VALVES AND ISOLATION VALVE ARE TO BE CLOSE TO THE COLUMN AND AT THE SAME PLANE OR ABOVE OF THE NOZZLE. 12- DELETED.
1"-OLW-011018302-101CS1P-N
ZC 0342
20"
NOTES
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
MIN.
L2A
BY-PASS ZHA 0006
OPEN ZLO 0006
CLOSED POSITIONER ZLC 0006
OLW
ZYC 0006
ZHS
ZLS
ZLS
ZY
0006
0006 O
0006 C
0006
ATM. RESIDUE FROM 011-G-0014
DS011-TRJR-480066 3280
DS011-TRJR-480066 3281
05
13-MAR-2013
AB
04
30-SEP-2011
03
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
DESCRIPTION
19 N.A. 20 FUEL OIL 21 FUEL GAS 22 N.A. 23 N.A. 24 N.A. 25 CLOSED DRAIN 26 N.A. 27 L.P. NITROGEN 28 H.P. FLARE 29 L.P. FLARE 30 SOUR/ACID FLARE 31 PILOT GAS 32 AUX COOLING WATER 99 ON-OFF VALVE DETAIL FLO FLUSHING OIL
9 8 7 6 5 4
HAGO TO 011-C-0006 & 011-G-0012 DS011-TRJR-480056 3278
HAGO VAPOR FROM 011-C-0006 DS011-TRJR-480056 3276
LAGO TO 011-C-0005 & 011-G-0010 DS011-TRJR-480054 3260
2 1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / STG
AVS / MAC
JAL
02
22-DEC-10
AFC
AFC: APPROVED FOR CONSTRUCTION
MSS / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
VJS / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION DESCRIPTION
10
3
5048
ATM RESIDUE
POS.
101CL4P 101CH2S
25
TO 011-G-0014
2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
mm mm barg °C barg °C
28
FC TSO NOTE 2
LI 0021
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001).
011-C-0002 VERTICAL 60950.0 7800.0 1.00 NOTE 6 119.00 NOTE 6 3.50 NOTE 8 200.00
TI
23
1
GENERAL NOTES
COLUMN TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
29
8"-CRU-011018001-101CL4P-H
20"-HFO-011018101-103CL4P-S
MIN.
D 2"x1"
LL
ZHXS
PI
0030
1/4"
4" S
HS 0005
2"-CLD-011018312-101CH2S-P
LAGO REFLUX FROM 011-G-0010
250mm MIN.
18"-LPS-011017001-101CS1P-H
36"-CRU-011017002-101CL2P-H
14"-HFO-011014007-101CL2P-H
8"-DIE-011026004-103CS2P-H
10"-HFO-011027004-103CL2P-H HAGO REFLUX
1"
IA DE
INST.
2
PIPING
MIN.
3
35
0109
ZLC 0079
2"-CRU-011018001-101CL4P-P
PIPING
D1
1
2"
D
4
2
TI
D 4"-MPS-011018301-103CS1P-H 3/4" UC
0079 CLOSED
+
0110
2189
H
0308
ZC 0351
S
ZV 0079
TT
3
L2B
ZHSR
ZYV 0079
8"
4
L3B
ZC
A3
L3A
10
NOTE 11
101CL4P 101CS1P
INST. PIPING
2" 1/4" 2"
MIN. INST.
1"-HFO-011018102-103CL4P-S
6
0020
2" CL300
LI
LE
NUCL 0020 NOTE 5
LI 0018
NOTE 4
2"
5
2"
25 5044
0079 L
6
P1
MAG
7
2" 1/4"
8"
12" A2A
2"
ZC 0351
NOTE 3
0110
P2
A1
12" A2B
18"x12" PI 0032
TI 0108
LT 0018
28"
14
11500
12
2" 1/4"
T2
18"-LPS-011018001-101CL4P-H
NC
0078
33
ES
ZHXS
B2
36"
1"-CRU-011018003-101CL4P-S
0078
30
INST.
B3A
ID 24"
PIPING
18"x12"
MIN.
D 2"x3/4"
2"-CLD-011018310-101CH2S-P
13
3/4"
0078 O
32
28"-HFO-011018001-101CL2P-H NOTE 1
P3
2"
0.2%
1"-LFL-011018310-101CH2F-N
2075
TT 0108
T1
101CH2F 101CL4P
14
29
0078 C
12"-HFO-011024002-101CL2P-H NO POCKET
28" B3B
HPT
MIN.
15
36"-CRU-011017002-101CL2P-H
250mm MIN.
3/4"-HFO-011018003-103CL2P-P
17 16
8"x4"
NC MIN.
2"
2"
3050
4"
ZHS
31
2"
10" 2"
INST.
ZY
FC TSO NOTE 2
+
2"
L5A
A4
PI 0031
ZLS
34
PUMP STOP
2"
10"-HFO-011018002-101CL2P-H
25
8"x4"
0107
INSTR.
19 18
0107
36
ZLS
0078
ATM
ZV 0078
2"
M3
101CL2P 101CH2S
TI
12"x10"
PIPING
+
10"x6"
PUMP STOP
37
0106
ZHXS ES
0350
TT
2"
2"
MIN.
MIN
25 5043
INST. PIPING
2"
1/4"
1/4"
38
TT
+
T3
19
PIPING 2" 2" 2"
0016
MAG
0078
12"x10"
10" A6A
ID 24"
M4
10" A5A
2"
LT
L
FT
MIN.
21
FC
INST.
250 mm
103CS2P 101CH2S
PIPING INSTR.
103CL2P 101CL2P
22
3/4"
0078
A6B
14"x10"
3/4" 2"x3/4"
0015
2"
10"
0078
DE
28"-DIE-011018001-101CS2P-H NOTE 1
T4
29 20
14"x10" D
0015
LL
B4B 28" 28" B4A
30
101CH2F 101CL2P
3/4"-HFO-011018006-101CL2P-P 14"-HFO-011014007-101CL2P-H
5046
ZC
1/4"
PIPING
A7
NC
25
ID 24"
M5
2072
2"-CLD-011018303-101CH2S-P
8"x4"
NC
2"-CLD-011018309-101CH2S-P
23
4"
LI
NOTE 7
MIN.
25 24
2" 2"
8"
250mm MIN.
3/4"-DIE-011018005-103CS2P-P
26
INST.
29
LT
L8A
3/4"-LFL-011018304-101CH2F-N
2"x3/4"
2" 2"
L10A
MIN.
8"x4"
30
27
HPT
NC
101CS2P 101CH2S
28
1/4"
8"-DIE-011018002-101CS2P-H
31
29
MAG
0078 IA
1/4" L9A
FC
MIN.
32
8"x6"
MIN.
3/4"
2"
ZHA
28"-DIE-011018001-101CS2P-H
FV 0024
34
INSTR.
250 mm MIN.
1/2"
103CS2P 101CS2P
1/2"
PIPING
3/4"-DIE-011018008-101CS2P-P
INST. PIPING
35
LG 0014
L
ZYC
39
12"-HFO-011024002-101CL2P-H
FT 0024
36
0013
L8B
2" 2"
ZLO
28"-HFO-011018001-101CL2P-H
0013
1/4"
ZLC
S
DETAIL "A" 3m MIN.
2"-CRU-011018004-101CL4P-P
0024
LT
31
+
40
TI 0106
OPEN POSITIONER BY-PASS
CLOSED
ZYV 0078
PIPING INST. 2" 2"
0350
ZHSR 0078
2"-CLD-011018307-101CH2S-P
MIN.
L9B
H
LC
ZC 0309
MIN.
FC
37
ZHXS 0078 L
L10B
2"
3/4"
ES
101CS1P 101CL4P
NC
38
TRIM: HFO-011018601-103CL2P / DIE-011018601-103CS2P / HFO-011018101-103CL4P / CRU-011018601-103CL4P
INSTR.
PIPING
ZC
NOTE 3
MIN.
NOTE 7
39
NOTE 9
3/4"-DIE-011018009-101CS2P-P
101CH2F 101CS2P
29 5045
41
250mm MIN.
40
011-C-0002 ATMOSPHERIC COLUMN
HPT
101CL4P 101CS1P
3/4"-LFL-011018303-101CH2F-N
8"-HFO-011027114-101CL4P-S
41
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 011-075 011-080 011-220 011-077
Item Tags : 011-C-0002
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE DISTILLATION COLUMN ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480044.pid
Discipline: PRO
SA-JER-DS011-TRJR-480044 2271-011-PID-0021-018
REV:
05
Sheet: 2 of 2
SCALE: NONE Format:
A1
011-A-0001-A / B / C / D / E / F / G / H / I / J / K / L / M / N / O / P CDU OVERHEAD CONDENSER
41 40
41 40
NOTE 5 HPT
39
39
2"-LFL-011019303-101CH2F-N 38
29
TI
NOTE 1
0361
37
NC
2"-NAP-011019032-101CH2S-P
36
TT
34
37 36 35
MIN
V
10ø MIN.
2"
2" CL300
2"-NAP-011019022-101CH2S-P
V
34 33
34"-NAP-011002001-101CH2S-P
TWO PHASE FLOW
32
34"x20"
34"x20"
20"
32
MIN
33
101CH2F 101CH2S
2"
0361
35
38
3969
31
20" 31
HPT
30
20"x16"
16"
20"x16"
20"x16"
16"
16"
30
20"x16"
16"
29
29
NOTE 7
28
16"
16"
16"
28
16"
16"
16"
16"
16"
27
27
N2
N2
6"
D
011-A-0001-E N4
N4
6"
D
011-A-0001-F
N2
N2
6"
D
011-A-0001-H
011-A-0001-G
N4
N4
6"
D
N2
N2
6"
D
011-A-0001-I
011-A-0001-J N4
6"
N4
D
N2
N2
6"
D
011-A-0001-K
6"
011-A-0001-L
N4
N4
D
N2
N2
6"
D
011-A-0001-M
011-A-0001-N
N4
6"
N4
D
N1
N1
N2
N2
6"
D
10"
011-A-0001-O N4
6"
N4 1-1/2"
D
011-A-0001-D
N1
10"
1-1/2"
6"
N4
N1
10"
1-1/2"
N4
10"
1-1/2"
6"
D
011-A-0001-C
N1
N1
1-1/2"
N2
N1
N1
10"
26
NOTE3
NOTE3 10"
1-1/2"
N2
10"
1-1/2"
D
011-A-0001-B
N1
N1
10"
10"
1-1/2"
1-1/2"
6"
23
N4
N4
N1
N1
10"
1-1/2"
011-A-0001-A
N2
N1
N1
10"
10"
10"
1-1/2"
24
1-1/2"
N1
10"
1-1/2"
10"
10"
25
NOTE3
NOTE3
NOTE3
NOTE3
1-1/2"
NOTE3
1-1/2"
NOTE3
1-1/2"
26
D
25
N1
011-A-0001-P
24
N2 6"
D
23
22
22
M
21
M
M
M
M
M
M
M
M
M
M
M
M
M
M
M
21
13
MA 0001 D
NOTE 6
NOTE 6
TYP.7
MA 0001 E
MA 0001 F
NOTE 6
NOTE 6
ZC 0410
MCC
TYP.8
TYP.7
MA 0001 G
MA 0001 H
NOTE 6
NOTE 6
ZC 0410
MCC
MCC
TYP.8
TYP.7
MA 0001 I
MA 0001 J
NOTE 6
NOTE 6
ZC 0410
MCC
MCC
TYP.8
TYP.7
MA 0001 K
MA 0001 L
NOTE 6
NOTE 6
ZC 0410
MCC
MCC
TYP.8
TYP.7
MA 0001 M
MA 0001 N
NOTE 6
NOTE 6
MCC
ZC 0410
MCC
TYP.8
TYP.7
MA 0001 O
MA 0001 P
NOTE 6
NOTE 6
6"-NAP-011019031-101CH2S-P
NOTE 6
MA 0001 C
TYP.8
MCC
6"-NAP-011019031-101CH2S-P
NOTE 6
TYP.7
MCC
6"-NAP-011019031-101CH2S-P
MA 0001 B
TYP.8
ZC 0410
MCC
6"-NAP-011019031-101CH2S-P
MA 0001 A
MCC
6"-NAP-011019031-101CH2S-P
TYP.7
ZC 0410
6"-NAP-011019031-101CH2S-P
TYP.8
MCC
6"-NAP-011019031-101CH2S-P
14
MCC
6"-NAP-011019031-101CH2S-P
15
ZC 0410
6"-NAP-011019031-101CH2S-P
16
MCC
6"-NAP-011019031-101CH2S-P
17
6"-NAP-011019031-101CH2S-P
18
6"-NAP-011019031-101CH2S-P
18
6"-NAP-011019031-101CH2S-P
19
6"-NAP-011019031-101CH2S-P
19
6"-NAP-011019031-101CH2S-P
20
6"-NAP-011019031-101CH2S-P
20
17 16 15 14 13
02
12
12
10"
10"
11
11
MIN.
2"-NAP-011019001-101CH2S-P
8
2" 7 6 5 4
101CH2S
101CS1P
2"-NAP-011019001-101CH2S-P
TT
8
0114
2"
10ø MIN.
7
2" CL300
6
NAPHTHA TO 011-D-0004 4186 5
2"-NAP-011019035-101CH2S-P
4
1-1/2"
3
MIN.
MIN.
MIN. 3/4"-OLW-011019306-101CS1P-N
3/4"-OLW-011019301-101CS1P-N
OLW
1
2"-CLD-011019306-101CH2S-P OLW
2"-CLD-011019306-101CH2S-P
25
CDU NAPHTHA OVERHEAD FROM 011-E-0003
3074
DS011-TRJR-480004 2814
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 4- DELETED. 1- MAKE CONNECTION ON TOP OF PIPE. 2- OP. TEMP. ºC IN / OUT: 95 / 60. 3- 1% SLOPE IN LAST PASS OFF TUBE BUNDLES IS TO BE CONSIDERED. 5- AIR COOLER HAS 8 BAYS WITH 2 MOTORS / FANS EACH AND 2 BUNDLE PER BAY. AIRFINS TYPE SURFACE OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP DUTY
9
3/4"
1-1/2"-NAP-011019034-101CH2S-P
250mm MIN.
1
10
0114
2
34"-NAP-011002001-101CH2S-P
2
TI 2"
12"-NAP-011019001-101CH2S-P
1-1/2"
3
MIN.
101CH2S 101CS1P
3/4"
2"-NAP-011019009-101CH2S-P
10 9
NOTE 7
12"x10" 12"x10"
1-1/2"-NAP-011019033-101CH2S-P
MIN.
m² barg °C barg °C Gcal/h
011-A-0001-A TO P FORCED 2978.0 0.60 95.00 3.50 130.00 26.72
6- VIBRATION TRIP IS REQUIRED FOR EACH MOTOR AS PER MOTOR TYPICAL. 7- PIPING ARRANGEMENT TO BE SYMETRICAL. NOTE 2
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV/ STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JGT / FCB
RDP / MAC
JAL
REV
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CDU OVERHEAD CONDENSER
011-074 011-076 Item Tags :
011-075 011-080
ORIGINAL SIGNED IN PROJECT FILE
011-A-0001 A TO P
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480045 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480045 2271-011-PID-0021-019
REV: 05
Sheet: 1 of 3
SCALE: NONE Format:
A1
41
36
6"
6"
3/4" D
3"x1-1/2" 1-1/2"
3"x1-1/2"
34
3/4"-NAP-011019029-101CH2S-P
NC
SPLIT RANGE
33
MIN. 3/4"
3/4" V
32
0%-45% HPT
4"-NAP-011021003-103CH2S-P
29
31
HPT 3/4"
55%-100%
PY 0033
6982
D
NOTE 7
101CH2F
30
MIN.
27
+
PZV 0011 A
3/4" 18"x10"
+
0033
INST. PIPING MIN.
LPT
12"
24
011-D-0004 23
2" 4" 4" 2" V1 P1
2" P2
E1
PIPING
3/4" 18"x10"
+
18"x8"
NOTE 12
NOTE 9
3/4" V
NOTE 12
2"
2" ZC 0343
M1
3/4"-NAP-011019023-103CH2S-N MIN.
2" 3/4"
FB
16
2"-CLD-011019308-101CH2S-N NO POCKETS
15
13
1/4" D LDG
LDT
D
0025
0026
3/4"-NAP-011019027-101CH2S-P
5049
101CH2S 101CH2F
1/4" D INST.
11
INST. PIPING
3/4"-LFL-011019305-101CH2F-N
12"-NAP-011019001-101CH2S-P
0019
0320
LDI 0027
L
FMC
V
28
MIN.
2" D
1/4"
2"
26
23
LT
LC
0024
0024
22
MAG
H
LG 21
0023
L
INST.
PIPING 2"
20 TO FC-0025 4195
ES ZHXS
FC TSO
0007
0343
L6B
0007 L
ZYV 0007
NOTE 2
ZC
ZHSR
0303
0007
19
ZC
ZHXS ES
NOTE 1
+
12"
24
MIN.
ZV 0007
B1
18
RESET CLOSED
OPEN
POSITIONER
BY-PASS
ZLC
ZLO
ZYC
ZHA
0007
0007
0007
0007
17 16
S
15
L6A
IA ZLS
ZLS
ZY
ZHS
0007 C
0007 O
0007
0007
14
ATM
13
12"-NAP-011019002-101CH2S-P
B2
PIPING D1 4"
27
3/4"
3/4"-NAP-011019024-101CH2S-P
L5A L4A
2"
29
ZYV 0008
6"
+
ZHXS 0008 L
S
FC TSO
IA
4"-OLW-011019305-101CS1P-N
ZV 0008
ES
NOTE 1
ES
ZC
ZHSR
0375
0008
RESET
CLOSED
OPEN
POSITIONER BY-PASS
ZLC
ZLO
ZYC
ZHA
0008
0008
0008
0008
3/4"
NAPHTHA TO 011-G-0005-A/B 4198 12 11
INST. NC PIPING
10 9
+
ATM
ZHXS
ES
0008
ZLS 0008 C
ZLS 0008 O
ZY 0008
8
ZHS 0008
7 6
3/4"-AWS-011019004-101CH2S-P
3/4"-AWS-011019004-101CH2S-P
5
3"-AWS-011044017-101CH2S-P 4
LPT
011-SC-0028
SC 3/4" D
TYPE 14 AT
NOTE 10
0019 pH
FROM/TO 011-D-0006 DS011-TRJR-480113 3283
3857
SOUR WATER
NAPHTHA START-UP
TO 011-D-0006
FROM B.L.
DS011-TRJR-480113 3284
DS011-TRJR-480051 3253
2"x3/4" 2500mm
NAPHTHA
SIGNAL TO 011-X-0004 TO 011-AY-0019A/B DS011-TRJR-480126
MIN. 3/4"
CL300 CL300 PIPING INST.
2"
SAMPLE LINE
NC 4"x3" 3"
3/4"-AWS-011019006-101CH2S-P
4"x3" NOTE 8
6"-AWS-011019001-101CH2S-P 2"-AWS-011019010-103CH2S-P
6"x3" FC 6"x3" CL300 3/4" D 3/4" D
MIN
RETURN SAMPLE LINE
4"-NAP-011021003-103CH2S-N NOTE 4
6"-AWS-011019001-101CH2S-P
EQUILIBRIUM LINE
4"-NAP-011019004-101CH2S-P
2"
PIPING INST.
3/4"-AWS-011019008-101CH2S-P
2"-AWS-011019011-103CH2S-P
2
MIN.
3"
3
2"-AWS-011019012-101CH2S-P
101CH2S 101CS1P
LDV 0026
1/2"
PIPING 1/2" INST.
4"-AWS-011019004-101CH2S-P
4"-CLD-011019301-101CH2S-P
FT 0149
3 2
3/4"-OLW-011019302-101CS1P-N
OLW
FI
SOUR WATER FROM 011-D-0006 DS011-TRJR-480113
0149 25
8258
3049
25
1
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES
011-D-0004 HORIZONTAL 10200.0 2900.0 0.30 65.00 3.50 100.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MSS / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MSS / STG
AVS / MAC
JAL
01
17JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JCP / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
2"-CLD-011019309-101CH2S-P
6980
mm mm barg °C barg °C
3/4"
101CH2F 101CH2S
OLW
+
DRUM TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
3/4" NC
3/4"
INST.
ZV CLOSURE
NAPHTHA 4186FROM 011-A-0001
1
2"
4"-AWS-011019009-101CH2S-P 101CH2S LL 101CS1P
ZC 0375
MH D 1/4" 24"
M2
DE
ZC 0375
NOTE 12
INST.
MIN.
6
UC
NC 3/4"
H
PIPING 2"
250mm MIN.
7
AC
LDC 0026
30
D 3/4"
DE
1/4" D 2"
NOTE 7
10
2" 2"
31
5410
18"
+
D 1/4"
29
12
8
LDT 0027
HPT
25
6983
9
2" 2"
MAG 3/4"
PIPING 2"
2"
L1A
L4B 2" L5B
2"
INST. PIPING
103CH2S 101CH2S
L2A
L3A
1/4" D
17100 mm
17
2"
PIPING 2"
INST. PIPING
29
V NOTE 6 LO FB
FB LC
NOTE 6
32
NOTE 7
NOTE 9
LO
3/4"-LFL-011019304-101CH2F-N
25
NOTE 2 2"
INST.
2"
2"-NAP-011019025-101CH2S-P
3/4" 18"x10"
+
18"
L3B
1/4" D
LT 0022 LL
S1
NC
2"x3/4" 18
MIN.
D
2"
HPT
CL300 18"x8" 011-SP-0026
D 3/4"
NOTE 6
2"
L2B
3/4" V
UC
250mm MIN.
19
14
LI 0022
PUMP STOP
3/4"
20
33
PZV 0012
V NOTE 6 LO FB
CL300
E2 W1 2" L1B
INST.
22
MH 24"
34
24"
6"
NOTE 5
21
0.2 %
20"-LFL-011019302-101CH2F-N
24"-NAP-011019006-101CH2S-P
2"
4"
A1
35
+
18"
25
36
8"T10" 3.50
PZV 0011 B
V NOTE 6 LO FB
FB LO NOTE 6
PT
PI 0034
29 6981
NOTE 7
+
D 3/4"
12"-NAP-011019001-101CH2S-P
3/4"
37
NOTE 7
3/4"-LFL-011019307-101CH2F-N
8"T10" 3.70
3/4" V
26
4
8"T10" 3.50
18"x8"
103CH2S 101CH2S
2016
HPT
2017
PC 0033
28
29
NOTE 7
3/4"-LFL-011019306-101CH2F-N 4"-NAP-011019004-101CH2S-P
38
6"-LFL-011019301-101CH2F-N
29
CL300
29
39
D
3/4"
NC
3/4"-NAP-011019030-101CH2S-P
6"-NAP-011019005-101CH2S-P NO POCKET
35
5
FC TSO 3/4" D CL300 6"
CL300
FC TSO CL300
3/4" D
+
MIN.
2169
37
6"x2"
PV 0033 B
1/2"
1/2"
101CH2S 101CH2F
2"
40
MIN.
3"x2"
3"-FGS-011019301-101CS2P-S
INST. PIPING
H
101CH2S 101CH2F
21
+
FI 0114
101CH2S 101CH2F
38
TRIM: NAP-011019601-101CH2S / NAP-011019602-103CH2S INSULATION: N
PV 0033 A
101CS2P 101CH2S
39
FT 0114
101CH2F
40
101CH2S
011-D-0004 CDU REFLUX DRUM
101CH2S 101CH2F
41
3,11 DELETED. 1- LOCAL EMERGENCY SWITCH BEHIND FIREWALL OR IN SAFE LOCATION. 2- ENSURE THAT NOZZLES FOR LEVEL TRANSMITTERS ARE AT THE SAME ELEVATION. 4- NAPHTHA FILLING LINE. 5- FOR NOZZLES DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING. 6- BLOCK VALVE SHALL BE INSTALLED WITH THE STEM IN OR BELOW HORIZONTAL POSITION. 7- MAKE CONNECTION ON TOP. 8- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS011-TRJR-480275. 9- MECHANICAL LINK. 10- LOCATED INSELF STANDING RACK 12- PZV-0011 A/B/C, PZV-0012 SIZE HAVE BEEN CALCULATED TAKING INTO ACCOUNT CV RATED OF PV-0033A (CV=27.2) AND ITS BYPASS (Cv=17.8)
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CDU REFLUX DRUM
011-074 011-076 Item Tags :
011-075 011-080
011-D-0004
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480046.pid
Discipline: PRO
SA-JER-DS011-TRJR-480046 2271-011-PID-0021-019
REV:
05
Sheet: 2 of 3
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
37
36
36
35
35
34
34
FC 0025
33
33
32
32
31
31
FT 0025
29
1/2"
29
+
6"x4" CL300
27 26
12"-NAP-011019002-101CH2S-P
24 23
MIN.
8"x6"
8"-NAP-011019003-101CH2S-P
25
FV 0025
1/2"
3/4"-NAP-011019019-101CH2S-P
28
30
4"
28
6"x4"
FC CL300
6"x4"
4"
3/4"-NAP-011019020-101CH2S-P
INST. PIPING
MIN.
30
6"x4"
NC NOTE 9 TYPE 14
27 26 25 24 23
2" UC
2" UC
LPT
21
NOTE 3
MIN.
22
MIN.
SC
LPT
MIN.
NOTE 3
3/4"-NAP-011019018-101CH2S-P
011-SC-0006
MIN.
22
MIN.
21
3/4" FROM 011-LC-0024 4195
D 2"x3/4"
20
MIN.
20 19
19
NOTE 6
NOTE 5
10
MIN.
9
LPT CL300 12"x8" 8" " 4 / 1"x3 3/4"
8
PIPING INST. 3/4"
NOTE 8 6" 8"x6"
INST. PIPING
PI 0036
3/4"
M
2"
250mm MIN.
17
INST.
2"
PIPING
NOTE 7
2"-NAP-011019017-101CH2S-P
8"-NAP-011019014-101CH2S-P
2"-CLD-011019304-101CH2S-P
16
25 5050
AT
15
CORROSION
0034 14
2"-NAP-011019026-103CH2S-P 13 12
011-G-0005-B NOTE 5
CL300
AI 0034
18
PIPING INST.
LPT 12"x8" CL300 8" " 4 / 1"x3 3/4"
NOTE 8 6" 8"x6"
3/4"
11
PI NOTE 11
0037
10
RO 0013
CL300
+
9
3/4"
M
6"-NAP-011019003-101CH2S-P
INST. PIPING
11
0179
011-G-0005-A
3/4"
NAPHTHA 4198FROM 011-D-0004
PI
MIN.
12
PI 0176
12"-NAP-011019002-101CH2S-P
13
2"-NAP-011019016-101CH2S-P
14
8"-NAP-011019003-101CH2S-P
15
3/4"
16
AI 0034 12"-NAP-011019013-101CH2S-P
17
NOTE 6 CMS
12"-NAP-011019002-101CH2S-P
18
2"
7 6
MIN. 2"-NAP-011019016-101CH2S-P
MIN.
2"-NAP-011019017-101CH2S-P
5
0005 A
1
2"-CLD-011019302-101CH2S-P
TYP. 6 NOTE 10
0005 B 2"-CLD-011019303-101CH2S-P
25
OLW
25 3070
3 2
DS011-TRJR-480049 3254
NAPHTHA TO 011-C-0002
NAPHTHA TO 011-C-0002 DS011-TRJR-480043 3251
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
4
D
INSULATION: P
m³/h barg bar barg °C kg/m³
5
3/4"
NOTE 4
011-G-0005-A / B CDU REFLUX PUMPS
011-G-0005-A / B CENTRIFUGAL 330.0 7.46 5.79 13.00 65.00 680.0
6
NAPHTHA
3068
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
7
TO 011-E-0021
MG OLW
101CH2S 101CS1P
MIN.
ZC 0303
3/4"
MCC
6"-NAP-011019007-101CH2S-P
250 mm MIN.
MG
NOTE 4
ZC 0343
3"-NAP-011019008-101CH2S-P
2
TYP. 6 NOTE 10
3/4"-OLW-011019304-101CS1P-N
250 mm MIN.
ZC 0303
101CH2S 101CS1P
3
3/4"
MCC MIN.
ZC 0343
4
3/4"-OLW-011019303-101CS1P-N
8
1,2 DELETED. 4- DISMOUNTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION. 5- SUSCTION PIPING SHALL HAVE A STRAIGHT LENGTH OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER INMEDIATELY UPSTREAM OF THE NOZZLE. 6- CHECK VALVE SHALL BE INSTALLED HORIZONTALY. 7- CORROSION MONITORING SYSTEM. 8- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JER-DS011-TRJR-480253. 9- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS011-TRJR-480275. 10- THIS MOTOR WILL INCLUDE A SOFTWARE TRIP PUSH BUTTON INSTEAD OF A HARD WIRED FROM MCR AUX. PANEL AS PER JERES-C-102 AND JERES-J-601. 11- MULTI STEPS RESTRICTION ORIFICE (4 STEPS).
DS011-TRJR-480043 3249
05
13-MAR-2013
AB
04
30-SEP-2011
03
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
15-DIC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / STG
RDP / MAC
JAL
A
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MVF / JLM
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
1
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CDU REFLUX PUMPS
011-074 011-076 Item Tags :
011-075 011-080
011-G-0005 A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480047 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480047 2271-011-PID-0021-019
REV: 05
Sheet: 3 of 3
SCALE: NONE Format:
A1
41
41
011-A-0002-A/B / C/D / E/F NAPHTHA CONDENSER
40
40
HPT
NOTE 1 2"-LFL-011020301-101CH2F-N
39
39
29 2041
38
38
101CH2F 37
37
NC 101CH2S
2"-NAP-011020006-101CH2S-P
36
36
V 2"
V
NOTE 7
20"-NAP-011012004-101CH2S-P
34
35
MIN.
35
34
2"-NAP-011020005-101CH2S-P
2"
2"
33
33
2" 20"x16"
16"
16"-NAP-011012004-101CH2S-P
20"x16"
16"
31
16"-NAP-011012004-101CH2S-P 31
HPT
8"
8"
2"-NAP-011020008-101CH2S-P
30
29
2" V
2"
2"
2"
V
8"
8"
2"-NAP-011020007-101CH2S-P
8"
8"
30
32
MIN.
32
29
2"
2"
28
28
2"-NAP-011020005-101CH2S-P 27
27
26
26
25
25
24
24
23
23
N1
N1 21
N2
N4
N4
011-A-0002-A/B NOTES 4,5,6
M
18
N4 N4
8"
1-1/2"
M
8"
6"
22
011-A-0002-E/F
N2
N4 N4
21
NOTES 4,5,6 6"
D
D
M
1%
8"
N1
N2
NOTES 4,5,6 6"
D
8"
N1
011-A-0002-C/D
N2
6"
D
1-1/2"
1-1/2"
19
8" N1
N2
6" D
1%
8"
N1
N2
6"
20
8"
8"
M
20
D
19
1-1/2"
8"
1-1/2"
1%
8"
8"
1-1/2"
8"
22
M
M
18
17
17
16
MCC
MCC
TYP.7
15 14
TYP.7
MCC
ZC 0411
MCC
TYP.7
TYP.7 NOTE 3
NOTE 3
13
MCC
TYP.7
NOTE 3
ZC 0411
NOTE 3
16
MCC TYP.7
NOTE 3
15
ZC 0411
NOTE 3
MA
MA
MA
MA
MA
MA
0002 A
0002 B
0002 C
0002 D
0002 E
0002 F
14 13
12
12
11
11
10
10
9
9
MIN. 8
MIN.
2"
UC
2"
2"x1-1/2" 2"
7
6"
6
6"
NO POCKET
12"x10"
10"
TT 0116
12"x10"
10"
MIN.
2"x1-1/2"
20"-NAP-011012004-101CH2S-P
2"
2"
2"-NAP-011020009-101CH2S-P 1-1/2"
3/4"
4
2"
2" CL300 2"x1-1/2"
TWO PHASE FLOW
1-1/2" 1-1/2"
1
101CH2S 101CS1P
UC
250mm MIN.
3/4"-OLW-011020302-101CS1P-N
101CH2S 101CS1P
MIN.
MIN.
MIN.
101CH2S
101CS1P
UC
3/4"-OLW-011020301-101CS1P-N
NAPHTHA 2 TO 011-E-0021 4208
12"-NAP-011020001-101CH2S-P
3/4"
2"
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
NAPHTHA VAPOR
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / FBL
RDP / MAC
JAL
FROM 011-D-0003
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JGT / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
250mm MIN.
AB: AS BUILT
3/4"-OLW-011020303-101CS1P-N
OLW
OLW
OLW
DS011-TRJR-480023 3160
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1- MAKE CONNECTION ON TOP OF PIPE. 2- OP. TEMP. ºC IN/OUT: 110/65. 3- VIBRATION TRIP IS REQUIRED FOR EACH MOTOR AS PER MOTOR TYPICAL. 4- AIR COOLER HAS 3 BAYS WITH 2 MOTORS / FANS EACH AND 2 BUNDLES PER BAY. 5- SHUT DOWN PROTECTION DEVICES 2 ACCELEROMETERS HAS BEEN PROVIDED. 011-A-0002-A/B TO E/F FORCED 1396.0 2.90 NOTE 2 110.00 5.00 140.00 14.71
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
06
13-MAR-2013
AB
05
06-OCT-2011
04
25 3301
m² barg °C barg °C Gcal/h
3
1-1/2"-NAP-011020010-101CH2S-P
2"-CLD-011020301-101CH2S-P
AIRFINS TYPE SURFACE OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP DUTY
5
10"-NAP-011020001-101CH2S-P MIN.
10"-NAP-011020001-101CH2S-P
1-1/2"-NAP-011020003-101CH2S-P
1
7
NOTE 7
3 2
8
3/4"
6
4
UC
2"
3/4"
5
TI 0116
6- 1% SLOPE IN LAST PASS OF TUBE BUNDLES HAS BEEN CONSIDERED. 7- PIPING ARRANGEMENT TO BE SYMETRICAL.
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CONDENSER NAPHTHA
011-074 011-076 011-075 011-080
Item Tags : 011-A-0002 A/B/C/D/E/F
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480048.pid
Discipline: PRO
SA-JER-DS011-TRJR-480048 2271-011-PID-0021-020
REV:
06
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
011-E-0021 NAPHTHA TRIM COOLER
40
40
INSULATION ( SHELL / TUBE ): P / N
39
39
38
38
37
37
36
36
35
35
1"D2" 11.00 +
34
34
TZV 0001
33
33
+
32
2"-CWR-011020001-101CS1P-N
32
CL300
31
31
2"x1" 3/4"
30
30
2"-CWR-011020302-101CS1P-N
V NOTE 2
28
TI
27
0340 26 25
TT 0340
24
2" CL300
23
NOTE 1
TWO PHASE FLOW
TI 0117 2" CL300
NOTE 6
NAPHTHA 29 TO 011-D-0005 4210
10"-NAP-011020002-101CH2S-N
28
MIN.
29
27 26 25
LO FB
24
MIN.
23
12"-CWR-011020301-101CS1P-N
3
22
22
4705
3/4" D 21
21
20
20
19 18
3/4" 17
D
16"x12"
19
16"
18
12" A2
011-E-0021
B1 17
NOTE 3
B2 12"
16
A1 16"
16
15
15
12"x10"
16"x12"
14
14
13
13
MIN. 12"-CWS-011020301-101CS1P-N
3
12
TI 0118
4706
3/4" D
11
H
12 11
10
10
TT 0118
9
9
8
8
7
2" CL300
10"-NAP-011020002-101CH2S-N
7
6
6
5
5
4
4
3
3
NAPHTHA
12"-NAP-011020001-101CH2S-P
4208FROM 011-A-0002 A/B/C
2
6"-NAP-011019003-101CH2S-P
2 1
1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
NAPHTHA
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / FBL
RDP / MAC
JAL
FROM 011-G-0005-A/B
00
11-DEC-09
IFD
IFD: ISSUED FOR DESIGN
JVM / FBL
RDP / MAC
JAL
DS011-TRJR-480047 3254
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 3, 4, 5 DELETED. 1- CONNECTION IN VERTICAL PIPE SEGMENT AS CLOSE AS POSSIBLE TO E-0021 IN ORDER TO AVOID SURGE. 2- AT GRADE. AT SAFE LOCATION. 6- BLOCK VALVE SHALL BE INSTALLED WITH THE STEM IN OR BELOW THE HORIZONTAL POSITION.
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-E-0021 AES 2.40 6.00 71.30 36.50 43.00 42.00 5.50 11.00 105.00 80.00 674.3 3.95
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
13-MAR-2013
AB
04
30-SEP-2011
03
REV
GENERAL NOTES
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
05
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 NAPHTHA TRIM COOLER
011-074 011-078 Item Tags :
011-075 011-080
ORIGINAL SIGNED IN PROJECT FILE
011-E-0021
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480049.pid
Discipline: PRO
SA-JER-DS011-TRJR-480049 2271-011-PID-0021-020
REV:
05
Sheet: 2 of 2
SCALE: NONE Format:
A1
011-D-0005 TOTAL NAPHTHA DRUM
41
TRIM: NAP-011021601-101CH2S / AWS-011021601-103CH2S INSULATION: N
40 39
40 39
FT 0026
3/4"
D
CL300
FC TSO CL300
3/4"
34
6"Q8" 5.00
33
3"x1-1/2" NC 1-1/2"
32
3"x1-1/2"
SPLIT RANGE HPT
101CH2S 101CH2F
31 30
29
3/4"-NAP-011021024-101CH2S-S
PY 0038
3/4" 10"x8"
+
CL300 10"x6"
6951
NOTE 3
6"Q8" 5.00
NAPHTHA
10"-NAP-011020002-101CH2S-N
NOTE 13
27 26
H
PC
PI
0038
0100
L
25
PI 0039
PT 24
0038
23
21
HPT
3/4"-LFL-011021304-101CH2F-N
2"
2"
2" 2"
2"
2" P1
A1
011-D-0005
5051
NOTE 3
P2
4" V 4"
NC
19
E1
MIN. 3/4"
LI 0028
2" 2" MIN. INST.
L4B
2" 2"
14
MAG
L6A
8
LL
FMC
7
FI 6
ZC 0376
0150
6826
101CH2F 101CH2S
3/4"
26
NC
25
MIN.
24
3/4"
23
ZC 0376
PIPING INST.
22 21
ZHXS 0009
MH 24" 2"
LT
LC
0030
0030
ES 20
MAG
H
19
LG
NOTE 1
0029
L
ES ZHXS 0009 L
1/4"
ZC 0304
ZHSR 0009
18
ZC 0344
17
2"
B1 12"
INST. NC PIPING
PIPING INST.
16
ZYV 0009 +
CLOSED
S
ZLC 0009
IA DE
OPEN POSITIONER ZLO 0009
BY-PASS
ZYC 0009
15
ZHA 0009
14 13
ZLS 0009 C
ZV 0009
L4A INST. PIPING D1
101CH2S 101CS1P
2"
1/4"
ZLS 0009 O
ZY 0009
ZHS 0009
12
4"
4"
11
12"-NAP-011021022-101CH2S-N MIN.
B2
ES ZHXS NOTE 1 0010 L
MIN.
L
LDI 0033
4"-AWS-011021006-101CH2S-N
H
LDC 0032
27
29
+
2" 2"
9
2025
NOTE 3
3/4"-LFL-011021308-101CH2F-N
2" L5A
1/4"
NC
28
29
ATM
11
INST. PIPING
3/4"-LFL-011021303-101CH2F-N
29
L5B
L6B 1/4"
2" 2"
2"
2"
1/4"
LDT 0033
12
10
29
6825
3/4"
31 30
2"
L2A L1A 2"
150mm
LDT 0032
TO FV-0062 4213
2"
L3A
1/4"
LDG 0031
10"-LFL-011021307-101CH2F-N
NOTE 7 LO
FB 3/4" D LC NOTE 7
1/4"
2"
2"
S1
13
FB
3/4"
NOTE 2
M2
2"
PIPING
SIGNAL
HPT
PIPING INST. 2"
LT 0028
LL
3/4"-NAP-011021019-101CH2S-N
7600 mm
15
ZC 0344 PUMP STOP
MIN.
16
CL300
V
3/4"
L3B
1/4"
UC
NOTE 3
3/4" D
2"
L2B
101CH2F 101CH2S
2"-NAP-011021023-101CH2S-P MIN. 3/4" V
17
2"
2"
M1
6952
101CH2S 101CH2F
V
10" W1 2" L1B
INST. PIPING
MH 24"
18
3"
P3
NOTE 6
20
29
INST. PIPING
29
10"
32
29 2024
3/4" 10"x8"
10"x6"
011-SP-0027
HPT
3/4"-LFL-011021306-101CH2F-N
+
FB LO NOTE 7
33
3/4"-NAP-011021018-101CH2S-N
INST. PIPING
22
PT 0100
35
3/4"-NAP-011021025-101CH2S-N
MIN.
0.2 %
NOTE 11
PZV 0015
10"-NAP-011021005-101CH2S-N
3"-NAP-011021004-101CH2S-N NO POCKET
PY 0021
28
2023
34
+
4210FROM 011-E-0021
36
29
3"x2"
2"
NOTE 2
3/4"-LFL-011021305-101CH2F-N
3"-LFL-011021302-101CH2F-N
NOTE 3
3/4"
NOTE 7 LO FB 10"-LFL-011021301-101CH2F-N
V
0.2%
3/4" D
NC
PZV 0014
55%-100%
3"x2"
NOTE 11
+
MIN. 3/4"
FC TSO CL300
3/4" D
D
3"x2"
FC TSO
ZYV 0010 +
ZV 0010 +
ZC
ZHSR
0376
0010
ZHXS 0010
S
12"-NAP-011021001-103CH2S-N RESET
ES
CLOSED
OPEN
BY-PASS
ZLC 0010
ZLO 0010
ZHA 0010
FC TSO
NAPHTHA 10 TO 011-G-0007-A/B 4219 9
103CH2S
2168
35
2"
3"x2"
3"-NAP-011021004-101CH2S-N
37
MIN.
2" 3"x2"
3"x2"
3"-FGS-011021301-101CS2P-S
1/2"
+
101CH2S
21
1/2"
INST. PIPING
MIN.
36
+
0%-45%
37
38
PV 0038 B
101CH2S 101CH2F
101CS2P 101CH2S
PV 0038 A
101CH2S 101CH2F
38
29
41
H
FI 0026
8 7 6
IA DE
ZV CLOSURE
5
MIN.
4"-OLW-011021304-101CS1P-N
ATM
FT 0150
3
LDV 0032
3/4"
D
2" 4"x2" FC CL300
4"-AWS-011021001-101CH2S-N
PIPING INST.
NOTE 12
4016
DS011-TRJR-480113 3255
RETURN SAMPLE LINE
3/4"-AWS-011021003-101CH2S-N
DS011-TRJR-480023
3"x2"
2"
2"x3/4"
NC 011-SC-0029 TYPE 23 SC AI 0020 AT 0020
mm mm barg °C barg °C
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
3/4"
3/4"-OLW-011021301-101CS1P-N
2"-AWS-011021007-103CH2S-N
3"x2"
3/4"-AWS-011021002-101CH2S-N 2"-CLD-011021305-101CH2S-N
pH NOTE 9
GENERAL NOTES
011-D-0005 HORIZONTAL 12000.0 3600.0 1.80 43.00 NOTE 8 6.00 95.00
3
MIN. 3/4"-AWS-011021009-101CH2S-N
2"
4"-AWS-011021004-101CH2S-N
D
3/4"
2"-AWS-011021008-103CH2S-N
SOUR WATER
5
1
101CH2S 101CS1P
CL300
TO 011-D-0006
0010
2
MIN.
4"x2"
4"-AWS-011021001-101CH2S-N
FROM PC-0021
0010 O
MIN.
+
1
SIGNAL
0010 C
3/4"-AWS-011021004-101CH2S-N
2"
PIPING INST.
250mm MIN.
1/2"
INST. PIPING
SAMPLE LINE
1/2"
ZHS
4
3/4"-AWS-011021004-101CH2S-N
MIN.
2
ZLS
LPT
250mm MIN.
4
DRUM TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
OLW
ZLS
4"-CLD-011021301-101CH2S-N
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JCP / FCB
RDP / MAC
JAL
PREPARED BY
CHECKED BY
OLW
25 3051
25 REV
6958
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER NOTES 4 POTABLE WATER 4, 5, 10 DELETED. 5 DEMI WATER 1- LOCAL EMERGENCY SWITCH BEHIND FIREWALL OR IN SAFE LOCATION. 2- MECHANICAL LINK. 6 N.A. 3- MAKE CONNECTION ON TOP OF LINE. 7 N.A. 6- FOR NOZZLES DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENT SEE MECHANICAL DRAWING. 8 N.A. 7- BLOCK VALVE SHALL BE INSTALLED WITH THE STEM IN OR BELLOW THE HORIZONTAL POSITION. 9 HP STEAM 8- HALF VACUUM AT 150ºC. 10 MP STEAM 9- LOCATED IN SELF STANDING RACK. 11 LP STEAM 11- PZV-0014 / 0015 SIZE HAVE BEEN CALCULATED TAKING INTO ACCOUNT CV RATED OF PV-0038A (Cv=27.2) AND ITS BYPASS (Cv=17,8). 12 HP CONDENSATE 12- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-DER-DS011-TRJR-480275. 13 MP CONDENSATE 13- OVERRIDE CONTROL FOR PREVENTING FLUSHING OF NAPHTHA BY LOW PRESSURE IN D-0005. 14 LP CONDENSATE 15 BFW 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A.
COMPANY STATUS
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 TOTAL NAPHTHA DRUM
Project:
011-074 011-076 011-075 011-080
Item Tags :
011-D-0005
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480050 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480050 2271-011-PID-0021-021
REV: 05
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
H
AI
37
0013 A 36
36
35
35
ASTM D86 95%
AT 0013
RETURN SAMPLE LINE
34
SAMPLE LINE
34
NOTE 6
33
33
32 31
32
FROM LC-0030 4213
31
FC
TI
0062
0119
SIGNAL
30
30
29
29
FT 0062
FV 0062 8"x6"
3/4"-NAP-011021013-103CH2S-N
23 22
INST. PIPING
21
MIN.
8"-NAP-011021002-103CH2S-N
24
20
INST. PIPING
+
26 25
27 26
6" 8"x6"
25
FC
3/4"
8"x4"
2"
2"
4"
8"x4"
NC NOTE 10 TYPE 23
011-SC-0007
24
NC
1/2"
0119
INST. PIPING
3/4"-NAP-011021014-103CH2S-N
27
1/2"
28
TT
MIN.
28
23 22 21 20
SC 19
19
3/4"-NAP-011021011-103CH2S-N
18
3/4"
18
D
UC
MIN.
LPT
NOTE 3
9
PI 0194
3/4"
PI 0042
PI 0195
INST. PIPING
3/4"
INST. PIPING
8"x6"
3/4"CL600 CL600
NOTE 2 12"x10"
7
INST. PIPING
3/4"
1/2"-NAP-011021015-103CH2S-N
M
12 11 10 9
INST. PIPING
011-G-0007-B NOTE 9
2"
NOTE 9
MIN.
MIN.
011-G-0007-A
2"
5052
CL600
3/4"
MIN.
MIN. 3/4"
5
M
PI 0043
8"x6"
CL600 NOTE 2 CL600 12"x10"
CL600 6
3/4"
13
25
3/4"-NAP-011021016-103CH2S-N
3/4"-NAP-011021015-103CH2S-N
8
14
4"-NAP-011021003-103CH2S-N
12"-NAP-011021001-103CH2S-N
15
2"-CLD-011021304-101CH2S-N 8"-NAP-011021010-103CH2S-N
NAPHTHA
4219FROM 011-D-0005
12"-NAP-011021009-103CH2S-N
11
12"-NAP-011021001-103CH2S-N
13
2"-NAP-011021015-103CH2S-N
8"-NAP-011021002-103CH2S-N
NOTE 3
16
103CH2S 101CH2S
MIN.
2"-NAP-011021016-103CH2S-N
14
12
NOTE 4
UC
15
10
2"
1/2"-NAP-011021016-103CH2S-N
4
7 6 5 4
MIN. 2"-NAP-011021015-103CH2S-N
3
2"-NAP-011021016-103CH2S-N
3
NOTE 5
0304
103CH2S 101CH2S
MG 0007 A
2"-CLD-011021302-101CH2S-N
ZC 0344 ZC
MCC TYP. 6 NOTE 11
0304
103CH2S 101CH2S
MG
OLW
0007 B
2"-CLD-011021303-101CH2S-N
3/4"-OLW-011021303-101CS1P-N
103CH2S 101CS1P
3/4"-OLW-011021302-101CS1P-N
250mm MIN.
TYP. 6 NOTE 11
103CH2S 101CS1P
ZC
MCC
MIN.
0344
1
250mm MIN.
ZC
MIN.
NOTE 5 2
3066
011-G-0007-A / B NAPHTHA TO NHDT PUMPS
25 3067
INSULATION: N
GENERAL NOTES
m³/h barg bar barg °C kg/m³
011-G-0007-A / B CENTRIFUGAL 292.0 18.50 15.39 28.00 43.00 650.0
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
NAPHTHA TO NHDT
DS011-TRJR-480046 3253
DS011-TRJR-480140 3257
05
13-MAR-2013
AB
2 1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / FBL
RDP / MAC
JAL
00
11-DEC-09
IFD
IFD: ISSUED FOR DESIGN
MVF / FCB
RDP / MAC
JAL
REV
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER NOTES 4 POTABLE WATER 1, 7, 8 DELETED. 5 DEMI WATER 2- PROVIDE A STRAIGTH OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 6 N.A. 3- CHECK VALVE SHALL BE INSTALLED HORIZONTALLY. 7 N.A. 8 N.A. 4- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 9 HP STEAM 5- DISMOUNTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION. 10 MP STEAM 6- LOCATED IN ANALYZER SHELTER 011-AS-0002 SEE P&ID Nº SA-JER-DS011-TRJR-480290. 11 LP STEAM 9- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JER-DS011-TRJR-480245. 12 HP CONDENSATE 10- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS011-TRJR-480275. 13 MP CONDENSATE 11-THIS MOTOR WILL INCLUDE A SOFTWARE TRIP PUSH BUTTON INSTEAD OF A HARD WIRED FROM MCD AUX. PANEL AS PER JERES-C-102 AND JERES-J-601. 14 LP CONDENSATE 15 BFW 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A.
NAPHTHA TO 011-D-0004
OLW
25
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
8
8"-NAP-011021002-103CH2S-N
2"
NOTE 4
17
250mm MIN.
LPT
2"
MIN.
MIN.
16
MIN.
2"x3/4"
17
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 NAPHTHA TO NHDT PUMPS
Project:
011-074 011-076 011-075 011-080
Item Tags :
011-G-0007-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480051 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480051 2271-011-PID-0021-021
REV: 05
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
011-C-0004 KEROSENE STRIPPER
011-E-0022 KERO STRIPPER REBOILER
TRIM: JET-011022601-103CS1P / JET-011022602-101CS1P
INSULATION ( SHELL / TUBE ) : H / H
PI 0044
TT 0120
INST. PIPING
39
2" CL300
H
12"-JET-011022001-101CS1P-H
6" 12"x6"
25
PIPING 3/4" INSTR.
PI 0045
NC
2" 2" 2" 2"
MIN.
5053
ZHXS 0011
P1
ZC A2
L3D
0387
28" 2" 2"
MAG LG 0035 A
NOTE 1
MAG LG 0035 B
2"
INST.
PIPING
LT
0034
0036
ZYV 0011
28"x24"
3/4"
2"
IA
12 11
ZLO
ZYC
ZHA
0011
0011
0011
0011
ZLS 0011 C
24" ATM
3/4" V 4"
4"-LPS-011022301-101CS1P-H
S1
ZLS 0011 O
7000 mm
CL150 D1 4"
4"-JET-011022021-101CS1P-H
D2 2"-JET-011022020-101CS1P-H
TT
TI
0122
0122
20"-JET-011022007-101CS1P-H ZV 0011
B3
MIN.
FC TSO
2"-JET-011022012-101CS1P-P
2"-CLD-011022301-101CH2S-P OLW
mm mm barg °C barg °C
MIN.
19
3/4"
3/4"-HFO-011022003-103CL2P-P 2"x3/4"
18
TI 17
0123
2"-CLD-011022304-101CH2S-P
3058
16
TT
15
0123
PDC
25
0046
5054
2"
13
KEROSENE TO 011-G-0009 4221 12
3/4"
PDV 0046
101CS1P 101CH2S
3/4"
+
11
3/4"
TT 0197
2"
INST. PIPING 3/4"
10"x8"
3/4"
10
FO 8" 03 TI 0124
10"x8"
8"
10"x8"
25
10"-HFO-011022001-103CL2P-H
TT 0124
9
2"
8 7
NC
MIN.
6
3/4"-HFO-011022005-103CL2P-P 2"x3/4"
5
TI
103CS1P 101CS1P 3/4"-OLW-011022001-101CS1P-N
0197
103CL2P 101CH2S
14"-HFO-011098001-103CL2P-H
14"-HFO-011022002-103CL2P-H
4 3
HAGO PA
2"-CLD-011022306-101CH2S-P
TO 011-E-0017
2
DS011-TRJR-480026 3196
25
1
5055
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JCP / JLM
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
HAGO PA FROM NAPHTHA SPLITTER REBOILER DS011-TRJR-480134 3259
NOTES
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
20
14"x12"
103CL2P 101CH2S
INST. PIPING
3/4"
25
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
COLUMN TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
14"x12" 12"
14
3052
GENERAL NOTES
NOTE 5 011-C-0004 VERTICAL 14400.0 3200.0 1.10 187.00 NOTE 7 3.70 220.00
PDT 0046
OLW
24"-JET-011018001-101CS1P-H
28"-JET-011018001-101CS1P-H
16"-JET-011022002-101CS1P-H
DS011-TRJR-480063 3258
103CL2P 101CH2S
3055
2
DS011-TRJR-480043 3247
MIN.
NC
MIN.
2"x3/4"
250mm MIN.
4
DS011-TRJR-480043 3248
21
3/4"
10"x8"
MIN.
4"-OLW-011022305-101CS1P-N
22
12"-JET-011022003-103CS1P-H MIN.
103CS1P 101CH2S
TO 011-G-0008
23
FC
12"-JET-011022003-103CS1P-H
12"-JET-011022022-101CS1P-H
5
KEROSENE PA
3/4"
+
3/4" 2"-OLW-011022304-101CS1P-N
24
14"x12"
14"x12" 12"
4"-HFO-011022004-103CL2P-P
LPT
MIN.
KEROSENE
LPT
25
20"
12" CL150
25
FV 0125
1/2"
2" CL300
7
FROM 011-C-0002
1/2"
18"x14"
ZHS 0011
3/4"-JET-011022011-103CS1P-P
TO 011-C-0002
1/2"
UC
20"-JET-011022007-101CS1P-H
B2
ZY 0011
11 2149
8
KEROSENE VAPOR
1/2"
4"-CLD-011022303-101CH2S-P
9
1
CL300
MIN.
2"
3
18"
INST. PIPING
BY-PASS
2"-CLD-011022302-101CH2S-P
6
B1
M1
4"-LPS-011022301-101CS1P-H
10
16"
20"
ZLC
101CS1P 103CS1P
13
3/4"-JET-011022011-103CS1P-P
3/4"-JET-011022011-103CS1P-P
14
CL300
DE
16 15
16"
26
+
OPEN POSITIONER
CLOSED
+
S
L2A
L3C 2" L3A 2" INST. PIPING 4" S2 CL150
INSTR. NC PIPING 3/4" NC
A2
28 27
0345
STOP PUMP
2" 2"
INSTR. PIPING
A3
A1
ZC 0345
FT 0125
ZC
0345 LL
L1A
17
B2
CL300
18"
ZC 0387
ZC
0036
L1B
2"
B3
CL300
ZHSR 0011
20"
CL300
FC 0125
HH
LT INST. PIPING 2" 2"
011-E-0022 RESET
LI
2"
L2B
2"
CLOSE FV0125
20"
CL300
ZHXS 0011 L
ZC 0305
L3B
NOTE 4
ES
ES
MIN.
18
1
29
FMC
MIN.
19
V
INST. PIPING 2"
25
18"x14"
28"
MIN.
20
3/4"
MIN.
21
MIN.
250mm MIN.
12"-JET-011022001-101CS1P-H
23
30
PIPING NC 3/4" INSTR.
101CS1P 101CH2S
2"-CLD-011022305-101CH2S-P
31
10 ø MIN.
2"x3/4"
32
V HPT
MIN.
D
26
2"
250mm MIN.
3/4"
101CH2F 103CS1P
2" CL300
NO POCKETS
28"-JET-011022008-101CS1P-H
V HPT
2"
MIN.
MIN.
MIN.
3/4"-JET-011022010-101CS1P-P
3/4" NC
33
0121
MIN.
NC
3/4"-JET-011022023-103CS1P-P
10"x6"
6"
28
22
TT
MIN.
FC CL300
10"x6"
24
10
29
3/4"
27
34
NOTE 8
30 29
M2
MIN.
MIN.
31
12"
6955
12"x6"
32
35
24" ID
MIN.
+
36
MIN.
LV 0034
0121
V1
A1
3/4"-LFL-011022301-101CH2F-N HPT
VERTICAL STRAIGHT LENGHT 1500 mm MIN.
TC
250mm MIN.
34
37
V 4"
B1
L
35
33
16" 4"
011-C-0004
MIN.
LC 0034
36
38
16"-JET-011022002-101CS1P-H
250mm MIN.
37
39
10 ø MIN.
NO POCKETS
INSULATION: H
6350 mm
38
3/4"
40
14"-HFO-011098001-103CL2P-H
H
TI 0120
250mm MIN.
40
41
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-E-0022 AXS 1.21 7.50 205.20 289.30 214.10 272.40 14.20 18.50 250.00 320.00 291.0 8.25
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
2,3 DELETED. 1- LOCAL EMERGENCY SWITCH BEHIND FIREWALL OR IN SAFE LOCATION. 4- ENSURE THAT NOZZLES FOR LEVEL TRANSMITTERS ARE AT THE SAME ELEVATION. 5- MAXIMUM PARAMETERS: OP. PRESS.: 1.2 barg OP. TEMP.: 214º C DES. PRESS.: 3.8 barg DES. TEMP.: 250º C 6- FULL VACUUM AT 250° C ON SHELL SIDE. 7- HALF VACUUM AT 150º C. 8- MAKE CONNECTION ON TOP OF PIPE. NOTE 6
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 KEROSENE STRIPPER
Project:
011-074 011-076 011-075 011-080
Item Tags :
011-C-0004
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
011-E-0022
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480052 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480052 2271-011-PID-0021-022
REV: 05
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
37
36
36
35
35
34
34
33
33
32
32
31
31
30
30
29
29
28
28
27
27
26
26
25
25
8"-JET-011022006-103CS1P-H
24
23
23
22
22
8"-JET-011022017-103CS1P-H
24
21 20 19 18
21 20 19 18
17
17
16
16
12"-JET-011022003-103CS1P-H 15
MIN.
KEROSENE 4221FROM 011-C-0004 15 14
MIN.
14
MIN.
MIN.
10 9
2"
PI 3/4" NOTE 5
PI 0203 INST. PIPING
LPT
INST. PIPING
011-G-0009-A NOTE 6
NOTE 2
3/4"
2"
PI 0048 PI 0209
M
011-G-0009-B
INST. PIPING 3/4"
CL600 1" x3 /4" 3/4"
3/4"
12
LPT
UC
NOTE 3
8"x4"
NOTE 1 12"x8" MIN.
7 6
NOTE 3
0047
3/4"
8
LPT
UC
2"
NOTE 2 10 9
3/4"
NOTE 6 8"x4"
LPT NOTE 1 12"x8"
INST. PIPING
2"
INST. PIPING
11
3/4" NOTE 5
8
CL600 1" x3 /4" 3/4"
M
3/4"
INST. PIPING
2"
MIN.
103CS1P 101CS1P
NOTE 7
ZC 0305
3/4"
0009 A
250mm MIN.
MG
1
MCC 3/4"-OLW-011022302-101CS1P-N NOTE 4
2"
103CS1P 101CH2S
TYP. 6
NOTE 7
ZC 0345 ZC 0305
3/4"
MG 0009 B
3/4"-OLW-011022303-101CS1P-N 2"
103CS1P 101CH2S
NOTE 4
OLW
2"-CLD-011022308-101CH2S-P
25
25
3056
3059
011-G-0009-A/ B KEROSENE PUMPS
05
13-MAR-2013
AB
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAIN SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1- PROVIDE A STRAIGHT LENGTH OF PIPE AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 2- CHECK VALVE SHALL BE INSTALLED HORIZONTALY. 3- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 4- DISMONTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
4
KEROSENE TO 011-E-0008
2
DS011-TRJR-480009 2888
1
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JVM / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
m³/h barg bar barg °C kg/m³
5
AB: AS BUILT
INSULATION: H
011-G-0009-A / B CENTRIFUGAL 250.0 12.00 9.59 18.30 214.00 624.0
6
OLW
2"-CLD-011022307-101CH2S-P
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
7
3
MIN.
TYP. 6 2
ZC 0345
MIN.
MCC
3
2"-JET-011022019-103CS1P-P
250mm MIN.
2"-JET-011022018-103CS1P-P 4
103CS1P 101CS1P
MIN. 5
8"-JET-011022006-103CS1P-H
11
2"
MIN.
12
13
12"-JET-011022005-103CS1P-H
12"-JET-011022004-103CS1P-H
13
5- FLANGED GLOBE VALVE TYPE. 6- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM:SA-JER-DS011-TRJR-480252. 7- THIS MOTOR WILL INCLUDE A SOFTWARE TRIP PUSH BUTTON INSTEAD OF HARDWIRED FROM MCR AUX. PANEL AS PER JERES-C-102 AND JERES-J-601.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 KEROSENE PUMPS
011-074 011-076 Item Tags :
011-075 011-080
011-G-0009-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480053.pid
Discipline: PRO
SA-JER-DS011-TRJR-480053 2271-011-PID-0021-022
REV:
05
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
011-C-0005 LAGO STRIPPER
40
TRIM: DIE-011023601-103CS2P TRIM: DIE-011023602-101CS2P INSULATION: H
39
41
011-Y-0005 011-C-0005 LP STRIPPING STEAM SILENCER
40 39
NOTE 2, 17
38
38
TT 0125
011-Y-0005
0049
37
36
4"-LPS-011023002-101CS2P-H
CLOSED 2" CL300
INST. PIPING
3/4"
35
1"-OLW-011023305-101CS1P-P
14"-DIE-011023002-101CS2P-H
NO POCKET 34 33
011-C-0005
32
3"
14"
NOTES 6, 18
V
OLW
B2
1500 mm MIN. NOTE 12
28 27 26
LV 0038
NOTE 20
ZHSR
0395
0377
0092
+
ZHXS 0092
S
NC
LC 0038
3/4"-DIE-011023009-101CS2P-P
H
INST. PI
PIPING INST.
0050 2" 2"
MAG
2" 2"
LG PIPING INST.
ZHS
0092 C
0092 O
0092
0092
2"-CLD-011023301-101CH2S-P
30
INST.
MAG INST. LG 0037 A PIPING 3/4"
TI 0363
ES
6" A2B
3/4" D NOTE 22
6"
PIPING 2" 2"
INST. PIPING 3/4"
12
3/4"-DIE-011023007-101CS2P-P
11 10 9 8 7
NC
27
L
TT
TI
0363
0364
FT 0027 INST. PIPING
NOTE 9
2" CL300
FV 0027
1/2"
ZC 0377
26
ZC 0320
25 24
1/2"
+
23
4" 6"x4"
8"x4"
LPT 3/4" D
FC CL300
CL300 3/4" D
21
L2B 2"
LT 0039
8"-LPS-011023004-101CS2P-H
ZC 0377
6"x4"
NC
NC
2"
2"
MH 24"
17
PUMP STOP V
D
2"-DIE-011023017-101CS2P-P
S1
UC
16
D
D
15
3/4"
MIN.
L1A
18
ZC 0347 3/4"
L2A
19
ST
L3B
2"
20
6"x4"
CLOSE STEAM INJECTION
LI 0039
M1
4"
4"
LL
L3C
2" 2"
28
ZC 0395
22
MIN.
FC TSO NOTE 4
FMC
FC 0027
2" CL300
14
L3A
NC
13
TI
23700 mm
5056
13
2"
2"
MIN.
25
28"x26"
L3D L1B
29
RESET
+
INST.
0038
2" 2"
14
PIPING
33
31
ZV 0092
HH
MIN.
250mm MIN.
15
6"
P1
LT
2"
101CS2P 101CH2S
6" A2A
PIPING 2" 2"
17 16
ZY
ATM
0037 B
3/4" 2"x3/4"
V
L
MIN.
18
ZLS
NC
1
3/4"
MIN.
8"x6"
6"
MIN.
0126 12 11
TT 0126
D1 12"
3" 3"-DIE-011023011-101CS2P-P
OLW
10
2" CL300
B1
9
LIGHT ATMOSPHERIC GASOIL 8 TO 011-G-0011 A/B 4224
12"-DIE-011023003-101CS2P-H
12"-DIE-011023003-101CS2P-H
NOTE 1
MIN.
19
3/4" 8"x6"
ZLS
DE
MIN.
20
FC CL300
MIN.
21
MIN.
MIN. 10"-DIE-011023001-101CS2P-H
22
0092
34
ZC
ZYV 0092
MIN.
6" 10"x6"
24 23
0092
IA 3/4"-DIE-011023016-101CS1P-P
10"x6"
0092
36 35
ZC
+
25
0092
6
2076
3/4"
ZHA
NOTES 16 ES ZHXS 0092 L
0320
24"
10"
29
101CH2F NC 101CS1P
ZYC
32
ZC
MH
M2
A1
3/4"-LFL-011023301-101CH2F-N HPT
ZLO
V1
30 29
ZLC
3"
31
10"-DIE-011023001-101CS2P-H
OPEN POSITIONER BY-PASS
101CS2P 101CJ1P
TI 0125
37
PI
101CS2P 101CS1P
7
6
6
3"-OLW-011023304-101CS1P-N 5
5
4
4
101CS2P 101CS1P
OLW
3
3
MIN.
LAGO VAPOR TO 011-C-0002 DS011-TRJR-480043 3245
2"-CLD-011023302-101CH2S-P
mm mm barg °C barg °C
OLW
1
LAGO
LAGO PA
25
STRIPPING STEAM
FROM 011-C-0002
TO 011-G-0010
3048
FROM 011-F-0001
DS011-TRJR-480044 3260
DS011-TRJR-480064 3261
DS011-TRJR-480042 3221
GENERAL NOTES
TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
3/4"-OLW-011023303-101CS1P-N
6"-LPS-011017005-101CJ1P-H
MIN. 101CS2P 101CH2S
250mm MIN.
2"x3/4"
26"-DIE-011018001-101CS2P-H
1
28"-DIE-011018001-101CS2P-H
2
14"-DIE-011023002-101CS2P-H
2
011-C-0005 VERTICAL 10900.0 2000.0 NOTE 14 1.30 243.00 NOTE 13 NOTE 15 3.90 370.00
SILENCER TYPE FLOW OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP.
Kg/hr barg °C barg °C
011-Y-0005 DIFFUSER+ABSORP. 1000.0 ATM NOTE 21 350.00 3.50 386.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER NOTES 4 POTABLE WATER 5, 7, 8, 10, 11, 19 DELETED. 5 DEMI WATER 1- FOR CONTINUATION REFER TO PID Nº 480056. COLUMNS 011-C-0005 AND 011-C-0006 ARE STACKED. 6 N.A. 2- TO ATMOSPHERE AT SAFE LOCATION. 3- 10 mm WEEP HOLE AT LOW POINT. 7 N.A. 4- MINIMUM DISTANCE FROM NOZZLE TO COLUMN 011-C-0005. 8 N.A. 6- ENSURE THAT NOZZLES FOR LEVEL TRANSMITTERS ARE AT THE SAME ELEVATION. 9 HP STEAM 9- MINIMUM DISTANCE AS POSSIBLE BETWEEN FV-0027 AND ZV-0024 (PID 480042) TO AVOID CONDENSATION. 10 MP STEAM 12- VERTICAL STRAIGHT LENGHT:1500mm (MIN). 13- OP. TEMP ºC TOP/BOTTOM: 243 / 234. 11 LP STEAM 14- OP. PRESS barg TOP/BOTTOM: 1,2 / 1,3. 12 HP CONDENSATE 15- DES. PRESS barg TOP/BOTTOM: 3,8 / 3,9. 16- LOCAL EMERGENCY SWITCH BEHIND FIREWALL OR IN SAFE LOCATION. 13 MP CONDENSATE 17- SILENCER INCLUDES ANTIBIRDS MESH. 14 LP CONDENSATE 18- FOR NOZZLES DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING. 20- MAKE CONNECTION ON TOP OF PIPE. 15 BFW 21- MAX OPPRESS barg: 1.6. 16 PLANT AIR 22- CHECK VALVE AND ISOLATION VALVE ARE TO BE CLOSE TO THE COLUMN AND AT THE SAME PLANE OR ABOVE OF THE NOZZLE. 17 INSTRUMENT AIR 18 N.A.
06
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
05
06-OCT-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MSS / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MRM / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JVM / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 LIGHT ATMOSPHERIC GASOIL STRIPPER
011-074 011-076 011-075 011-080
Item Tags :
011-C-0005
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
011-Y-0005 Electronic Filename SA-JER-DS011-TRJR-480054.pid
Discipline: PRO
SA-JER-DS011-TRJR-480054 2271-011-PID-0021-023
REV:
06
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
37
36
36
35
35
34
34
33
33
32
32
31
31
30
30
29
29
28
28
6"-DIE-011023006-103CS2P-H
27
26
26
25
25
24
24
23
23
22
22
21
21
12"-DIE-011023003-101CS2P-H
27
LPT
NOTE 6 3/4"
9
LIGHT ATMOSPHERIC GASOIL
PI
NOTE 4
16
011-G-0011-A NOTES 1,7
3/4"
6"x4"
NOTE 5 LPT. 12"x6"
1-1/2"-DIE-011023013-103CS2P-P
6"-DIE-011023014-103CS2P-H INST. PIPING
0051
14 13 12
INST. PIPING
11
PIPING INST.
0220 PI
15
PI
PIPING INST.
0218 INST. PIPING
12"-DIE-011023005-103CS2P-H
2"
011-G-0011-B
3/4"
NOTES 1,7
10
PI 0052
6"x4"
LPT.NOTE 5 12"x6"
7
M
1"x3/4"
MIN.
4224FROM 011-C-0005
MIN.
INST. PIPING HYDROCARBONS
1-1/2"
6
1/2"-DIE-011023006-103CS2P-P
M
1"x3/4"
1-1/2"
TO OLW DS011-TRJR-480250 10783
5
0347
103CS2P 101CS1P
ZC
MCC
2
TYP. 3
2"x1-1/2"
ZC
NOTE 3
0347
MIN.
3
1-1/2"-DIE-011023013-103CS2P-P
MIN.
3/4"-OLW-011023301-101CS1P-N
MCC 2"x1-1/2"
TYP. 3
103CS2P 101CH2S MG 0011 B
OLW
2"-CLD-011023303-101CH2S-P
3 LAGO TO 011-E-0011
3/4"-OLW-011023302-101CS1P-N
3054
25
011-G-0011-A / B LAGO PUMPS
3053
INSULATION: H
GENERAL NOTES
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
m³/h barg bar barg °C kg/m³
011-G-0011-A / B CENTRIFUGAL 194.0 13.95 10.29 20.00 234.00 680.0
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 1 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 2 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 4 NOTES 5 1- FUSIBLE TUBING TO BE ADDED AROUND PUMP FOR FIRE DETECTION. 6 2- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 7 3- DISMONTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION. 8 4- CHECK VALVE SHALL BE INSTALLED HORIZONTALLY. 9 5- PROVIDE A STRAIGHT LENGTH OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 6- FLANGED GLOBE VALVE TYPE. 10 7- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JER-DS011-TRJR-480250. 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
VJS / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS.
2
DS011-TRJR-480017 2958
OLW
2"-CLD-011023304-101CH2S-P 25
6
NOTE 3
250mm MIN.
250mm MIN.
MG 0011 A
7
4
1
103CS2P 101CH2S
8
MIN. 103CS2P 101CS1P
1-1/2"-DIE-011023012-103CS2P-P
4
9
5
MIN.
8
NOTE 6 3/4"
3/4"
10
NOTE 4
1-1/2"-DIE-011023012-103CS2P-P
11
NC
17
2"
UC
6"-DIE-011023006-103CS2P-H
12
UC
3/4"
13
19
LPT
101CS2P 103CS2P
12"-DIE-011023004-103CS2P-H
12"-DIE-011023003-101CS2P-H
14
NOTE 2
18
16 15
MIN.
6"-DIE-011023006-103CS2P-H
17
101CS2P 103CS2P
NOTE 2
1/2"-DIE-011023014-103CS2P-P
18
MIN.
MIN.
19
20
MIN.
20
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 LAGO PUMPS
Item Tags : 011-G-0011-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480055.pid
Discipline: PRO
SA-JER-DS011-TRJR-480055 2271-011-PID-0021-023
REV:
05
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
011-C-0006 HAGO STRIPPER
40
TRIM: HFO-011024602-103CL2P / HFO-011024601-101CL2P INSULATION: H
PI 0053 TT
TI
0127
0127
36
011-Y-0006
INST. 3/4"
2" CL300
37
39
PIPING
NOTE 5 ES
3/4"
TRJR VENDOR
NO POCKETS
NOTE 1 HPT
35
29
RESET
3/4"-LFL-011024302-101CH2F-N
37
ZHXS
ZC
0093 L
0395
36
ZHSR
ZC
ZC
0093
0378
0320
2077
34
38
NOTE 11
101CH2F 101CL2P
NC
32
ES
ZHXS 0093
12" B4
3" V2
MIN.
33
3" V
+
011-C-0006
3/4"
10"-HFO-011024015-101CL2P-H
CLOSED
OPEN
POSITIONER
BY-PASS
ZLC
ZLO
ZYC
ZHA
0093
0093
0093
0093
IA DE
NOTE 12
A3 24"
31
ZYV 0093
S
ID
ZC 0395
1500 mm MIN. NOTE 10
+
6" 10"x6"
10"x6" MIN.
27
LC
MIN.
28
FC CL300
0040 PIPING INSTR.
MIN.
26
H MAG LG
L
8"x6"
6"
8"x6"
INST. PIPING 2" 2" 2"
PI 0054
0041 B
LG
0366
2"-HFO-011024016-101CL2P-P
MIN.
21
P2
16 15
250mm MIN.
0093 C
0093 O
0093
0093
TI 0367
2" CL300
8"-LPS-011024004-101CS1P-H
FV 0028 +
8"x4"
LPT
MIN.
FC TSO NOTE 3
3/4" D
3/4" D
4"
4"
1/2"
PIPING
1/2"
29
8"x4"
FC NOTE 7 3/4" D CL300
28
CL300
27 26
6"x4"
25
NC
2" LT 0042
2"
L4A L5A
24
ZC 0378 LL
2"
3/4" V 2"-HFO-011024018-101CL2P-P
M3
L6A
LI 0042
1/4"
24" ID
2"
2"
30
INST.
HH
S2
6"
23
ST
CLOSE STEAM INJECTION
22
PUMP STOP
UC
21
D
ZC 0348
MIN.
D D 3/4" 3/4" 3/4" 20 19
3/4"
CL150
18
NC D2
3"-HFO-011024010-101CL2P-H 17
3" 12" B3
NOTE 5 ZHXS ES
2"-CLD-011024304-101CH2S-P
101CL2P 101CS1P
ZC
0080 L
0420
25
16
RESET
ZC
ZHSR
0307
0080
5057
14
2"
L4B
9000 mm
MIN. 10"-HFO-011024001-101CL2P-H
17
101CL2P 101CH2S
ZHS
TT 0366
31
FT 0028
PIPING INST. 2"
INSTR. INST. PIPING NC PIPING
INSTR. NC PIPING
ZY
32
0028
6"x4"
2"
3/4" 20
18
A4B
NOTE 18
6"
NOTE 6
2" 2"
2"
ZLS
FC
+
MIN. 8"
2"
2"
ZLS
34
FMC
L
CL300
INST. PIPING
22
ZV 0093
ZC 0320
33
OLW
L6D
INST. PIPING 2" 2" 2" L6B 2" 2" L6C 2" 2" L5B LT 0040
0041 A
19
A4A
6"
MAG
NC
23
1"
PIPING INSTR.
25 24
ATM
8"
MIN.
LV 0040
29
M4
3/4"-HFO-011024012-101CL2P-P
ZC 0378
TI
10"
30
35
1"-OLW-011024306-101CS1P-P
101CS1P 101CJ1P
38
40
NOTE 2, 14
4"-LPS-011024002-101CS1P-H
39
41
011-Y-0006 011-C-0006 LP STRIPPING STEAM SILENCER
12"-HFO-011024013-101CL2P-H
15
OLW
3"-OLW-011024302-101CS1P-N
14
MIN. 13
ZHXS
ES
13
0080
ZYV 0080
S
12
+
IA
11
DE
ZV 0080
OLW
+
12
101CL2P FC 103CL2P TSO
11
10
10
ATM TI 0128
ZC 0348
8 7
BY-PASS
6
ZHA 0080
POSITIONER OPEN ZYC 0080
ZLO 0080
TT 0128
CLOSED ZLC 0080
28"x26" 5
2"
4
ZHS
ZY
ZLS
ZLS
0080
0080
0080 O
0080 C
9
8"-LPS-011017006-101CJ1P-H
9
8 7 6 5
HAGO TO 011-G-0013-A/B 4227 4
12"-HFO-011024003-103CL2P-H
26"-HFO-011018001-101CL2P-H
3/4"-HFO-011024014-103CL2P-P
FROM 011-F-0001
103CL2P 101CS1P
DS011-TRJR-480042 3224
MIN.
2"-HFO-011024014-103CL2P-P
103CL2P 101CH2S HAGO PA
HAGO VAPOR
HAGO FROM 011-C-0002
TO 011-G-0012
DS011-TRJR-480044 3276
DS011-TRJR-480044 3278
DS011-TRJR-480065 3274
2"-CLD-011024301-101CH2S-P
mm mm barg °C barg °C
011-C-0006 VERTICAL 11700.0 2000.0 1.30 305.00 3.90 370.00
SILENCER TYPE FLOW OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP.
OLW
06
13-MAR-2013
AB
05
06-OCT-2011
04
Kg/hr barg °C barg °C
011-Y-0006 DIFFUSER+ABSORP. 1000.0 ATM NOTE 17 350.00 3.50 386.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER NOTES 4 POTABLE WATER 4,8,9,15 DELETED. 5 DEMI WATER 1- FOR CONTINUATION REFER TO PID Nº 480054. COLUMNS 011-C-0005 AND 011-C-0006 ARE STACKED. 6 N.A. 2- TO ATMOSPHERE AT SAFE LOCATION. SILENCER INCLUDES ANTIBIRDS MESH. 7 N.A. 3- MINIMUM DISTANCE FROM NOZZLE TO COLUMN 011-C-0006. 8 N.A. 5- LOCAL EMERGENCY SWITCH BEHIND FIREWALL OR IN SAFE LOCATION. 6- ENSURE THAT NOZZLES FOR LEVEL TRANSMITTERS ARE AT THE SAME ELEVATION. 9 HP STEAM 7- MINIMUM DISTANCE AS POSSIBLE BETWEEN FV-0028 AND ZV-0024 (PID-480042) TO AVOID CONDENSATION. 10 MP STEAM 10- VERTICAL STRAIGHT LINE OF 1500 mm MINIMUM. 11 LP STEAM 11- MAKE CONNECTION ON TOP PIPE. 12- FOR NOZZLES DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING. 12 HP CONDENSATE 13- 10 mm WEEP HOLE AT LOW POINT. 13 MP CONDENSATE 14- TO ATM. AT SAFE LOCATION. 16- TW SHALL BE INSTALLED IN HORIZONTAL SECTION OF THE LINE. 14 LP CONDENSATE 17- MAX OP. PRESS barg:1.6 15 BFW 18- CHECK VALVE AND ISOLATION VALVE ARE TO BE CLOSE TO THE COLUMN AND AT THE SAME PLANE OR ABOVE OF THE NOZZLE. 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A.
MJR / STG
AVS/ HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS/ MAC
JAL
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JCP / STG
RDP / MAC
JAL
REV
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
1
AB: AS BUILT
25 3019
GENERAL NOTES
COLUMN TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
250mm MIN.
3/4"-OLW-011024301-101CS1P-N
TO 011-C-0002
2
STRIPPING STEAM
MIN.
1
28"-HFO-011018001-101CL2P-H
2
3
12"-HFO-011024002-101CL2P-H
3
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 HEAVY ATMOSPHERIC GASOIL STRIPPER
011-074 011-076 Item Tags :
011-075 011-080
011-C-0006
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
011-C-0002
011-Y-0006
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480056.pid
Discipline: PRO
SA-JER-DS011-TRJR-480056 2271-011-PID-0021-024
REV:
06
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
37
36
36
35
35
34
34
33
33
12"-HFO-011024003-103CL2P-H
32
32
31
31
30
30
6"-HFO-011024006-103CL2P-H 29
29
XLC
XLS
0001
0001 C
0002
0002 C
XV 0001
ATM
XYV 0003
FC TSO
XV 0003
XV 0002
24
22 21
XV 0004 +
20
UC
MIN.
UC
25
FC TSO
+
2"
+
26
23
XYV 0004
FC TSO
+
19
0308
DE
0308
UC
+
2"
XLS 0004 C
NOTE 2
UC
+
+
20
XLC 0004
27
MIN.
21
XLS 0003 C
NOTE 2
XYV 0002
FC TSO
+
CLOSED
IA
IA
XYV 0001
0004 O
XLC 0003
S
ATM
UC 0307
0004
DE
22
UC 0307
DE
23
NOTE 2
0003 O
28
6"-HFO-011024007-103CL2P-H
XLS
NOTE 2
0003
IA
XLC
S
24
XLS
CLOSED
CLOSED
IA
25
XLO
S
CLOSED
26
XLS 0002 O
XLS
ATM
XLO 0002
XLO
DE
XLS 0001 O
OPEN
S
XLO 0001
27
OPEN
OPEN
ATM
OPEN
28
19
18
18
NOTE 5
NOTE 5
17
LPT
LPT
13 12 11 10
PI 0364
3/4"
NC
NOTE 4
3/4"
NOTE 7
PIPING
PI 0232
INST.
3/4"
0055
INST. PIPING
3/4"
9
011-G-0013-A NOTE 1, 8
MIN. 7
3/4"-HFO-011024006-103CL2P-P
3/4"
6"x3"
LPT /4" 1"x3
PIPING INST. 3/4"
0233
3/4"
M
15
NOTE 7
PI
MIN.
NOTE 3 12"x6"
8
PI
NOTE 4
3/4"
PI 0365
12"-HFO-011024005-103CL2P-H
14
12"-HFO-011024004-103CL2P-H
12"-HFO-011024003-103CL2P-H
3/4"
PIPING INST.
0056
INST. PIPING
011-G-0013-B
/4" 1"x3
13 12 11 10
3/4"-HFO-011024007-103CL2P-P
NOTE 1, 8
NOTE 3 12"x6" LPT
PI
14
6"x3"
M
1-1/2"
1-1/2" 6
ZC
NOTE 9
2"x1-1/2"
0348
2 1
MG
UC
0013 A
0307
103CL2P 101CH2S 2"-CLD-011024302-101CH2S-P
TYP.6 NOTE 9
NOTE 6
25 3032
ZC 0348
MG
3/4" 2"x1-1/2"
UC
0013 B
103CL2P 101CH2S
0308
OLW
2"-CLD-011024303-101CH2S-P 25 3031
NOTE 6
3 HAGO TO 011-E-0012
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1- FUSIBLE TUBING TO BE ADDED AROUND PUMP FOR FIRE DETECTION. 2- CLOSING SUCTION OR DISCHARGE VALVE AUTOMATICALLY STOPS ASSOCIATED PUMP (VIA DCS UC-0307, 0308) IN CASE OF LOSS OF OPEN POSITION. 3- PROVIDE A STRAIGHT LENGTH OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 4- CHECK VALVE SHALL BE INSTALLED HORIZONTALLY. PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
m³/h barg bar barg °C kg/m³
011-G-0013-A / B CENTRIFUGAL 173.0 13.70 10.89 20.00 295.00 690.0
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
5- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 6- DISMONTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION. 7- FLANGED GLOBE VALVE TYPE. 8- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JER-DS011-TRJR-480250. 9- THIS MOTOR WILL INCLUDE A SOFTWARE TRIP PUSHBUTTON INSTED OF A HARDWIRED FROM MCR AUX.PANEL AS PER JERES-C-102 AND JERES-J-601.
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
1
OLW
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MSS / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESING
IRG / JLM
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION DESCRIPTION
2
DS011-TRJR-480017 2959
INSULATION: H
POS.
6
4
011-G-0013-A / B HAGO PUMPS
GENERAL NOTES
7
103CL2P 101CS1P
3/4"
8
5
3/4"-OLW-011024304-101CS1P-N
0420
ZC 0420
250mm MIN.
0307
ZC 0307
MCC
MIN.
TYP.6
ZC
3/4"-OLW-011024303-101CS1P-N
3
ZC
103CL2P 101CS1P
MCC
MIN.
HAGO 4227FROM 011-C-0006
250mm MIN.
4
MIN.
1-1/2"-HFO-011024008-103CL2P-P
5
MIN.
1-1/2"-HFO-011024009-103CL2P-P
9
6"-HFO-011024006-103CL2P-H
INST. 1-1/2"-HFO-011024008-103CL2P-P
PIPING
15
16
1-1/2"-HFO-011024009-103CL2P-P
16
17
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 HEAVY ATMOSPHERIC GASOIL PUMPS
011-074 011-076 011-075 011-080
Item Tags :
011-G-0013-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480057.pid
Discipline: PRO
SA-JER-DS011-TRJR-480057 2271-011-PID-0021-024
REV:
05
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
41
011-E-0023 KEROSENE COOLER
40
40
INSULATION ( SHELL / TUBE ) : P / N
39
39
38
38
37
1"D2" 14.10
37
36
TZV 0002
36
+
+
2"-CWR-011025001-101CS1P-N
35
35
CL300 2"x1" MIN.
34 33
NOTE 1 32
301F0W
FB LO
3/4" D NOTE 4
33
2" CL300
2"-CWR-011025304-101CS1P-N
101CS1P
34
TI 0129
32
MIN.
31 3
30
4707
31
10"-CWR-011025301-101CS1P-N
10"-CWR-011072307-301F0W-N UG
AG
12"x10"
3/4" D 29
29
12" B1
28 27
30
011-E-0023 8" A2
28
B2
A1
27
8"
12" 26
26
MIN. 25
3
12"x10"
10"-CWS-011025301-101CS1P-N
RATIO
4708
24
25
UC 0321
3/4" D
24
23
23
22
FY 0139
21
22
FY 0118
21
20
20
FY 0029
19
TI
18
H
FT FT
0029
0029
TT 0130
FV 0029
1/2"
+
PIPING INST.
10 9
6" 8"x6" NC
011-SC-0019
SC
TYPE 5
3/4"-JET-011025008-103CS1P-N 2"x3/4"
MIN.
2"-JET-011025007-103CS1P-N
NOTE 2
2" D
2"-CLD-011025313-101CH2S-P
5
2"-CLD-011025301-101CH2S-N
AI 0022 A
AT 0022
INST.
95% ASTM D86
NOTE 2
OVERRIDE
2"
MIN.
PIPING
103CS1P 101CH2S
2"
AI 0011 A
AT 0011
INST.
SIGNAL FROM FC-0139
SIGNAL FROM B.L.
DS011-TRJR-480003
DS011-TRJR-480135
3636
3789
KEROSENE TO SLOP/STORAGE DS011-TRJR-480133 3264
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 3, 7 DELETED. 1- AT GRADE AT SAFE LOCATION.
2- LOCATED IN SHELTER ANALYZER 011-AS-0001. SEE P&ID Nº SA-JER-DS011-TRJR-480289. 4- GATE VALVE SHALL BE INSTALLED WITH STEM IN OR BELOW THE HORIZONTAL POSITION. 5- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS011-TRJR-480274. 6- H.V. @ 150ºC SHELL SIDE.
IN/OUT IN/OUT
NOTE 6
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
10 9
PIPING 25
8 7 6 5
5060
FLASH POINT
4
2"
3 SIGNAL
KEROSENE
SAMPLE RETURN LINE
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
D
2"x3/4"
SAMPLE RETURN LINE
SHELL/TUBE SHELL/TUBE
11
NC
DS011-TRJR-480135 3266
KEROSENE FROM 011-E-0001 DS011-TRJR-480003 2794
05
13-MAR-2013
AB
04
30-SEP-2011
03
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
DS011-TRJR-480135 6868
1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MVF / STG
RDP / MAC
JAL
REV
DATE
UTILITIES IDENTIFICATION POS.
2
TO B.L.
TO LP HDS
8"-JET-011001001-103CS1P-H
SAMPLE RETURN LINE
011-E-0023 AES 9.30 6.00 80.00 36.50 43.00 43.00 18.30 14.10 110.00 80.00 520.8 2.96
6"
2"-CLD-011025302-101CH2S-P
25
8"-JET-011025002-103CS1P-N
FREEZING POINT
8"x6"
5059
5058
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
0024
NOTE 2
4 3
0024 A
25
250 mm MIN.
103CS1P 101CH2S
AT
8"x6"
3/4"-JET-011025003-103CS1P-P
103CS1P 101CH2S
7 6
AI
12
PIPING
INST.
3/4"
3/4" D
MIN.
13
3/4"
MIN.
NOTE 5
8
MIN.
MIN. 8"x6"
14
8"-JET-011025001-103CS1P-H
2"
3/4"
FC
MIN.
PIPING INST.
6" 8"x6"
250 mm MIN.
2"
FC
15
8"x6"
MIN.
11
PIPING INST.
+
LPT
250 mm MIN.
2"
16
FV 0118
V
3/4"-JET-011025009-103CS1P-N
12
1/2"
INST. PIPING
4" 8"x4"
MIN.
13
3/4"-JET-011025010-103CS1P-N
8"x4" 14
2"
MIN.
15
17
0118
MIN.
FC
16
1
18
0130
17
2
19
FC 0118
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 KERO PRODUCTS COOLERS ORIGINAL SIGNED IN PROJECT FILE
Item Tags : 011-E-0023
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480058 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480058 2271-011-PID-0021-025
REV: 05
Sheet: 1 of 5
SCALE: NONE Format:
A1
41
41
011-A-0003-A/B LAGO COOLER
40
40
39
39
38
38
37
37
HPT
NOTE 1 3/4"-LFL-011025301-101CH2F-N
36
36
29 6393
35
35
101CH2F 103CS1P
34
34 33
MIN.
33
MIN.
32
32
3/4" V
31
31
3/4"-DIE-011025013-103CS1P-P 30
MIN.
30 29
29
HPT 3/4"
28
28
UC 27
27
26
26
6"
6"
25
25
24
24
23
23
22
22
6" 21
N1
20
N2
6" N1 N4
N4
011-A-0003-A/B NOTES 3, 4, 5
N2
6"
21 20
6" D
19
1-1/2" D
19
18
18
M
17
M
17
6"
6"
16
MCC
15
MCC
TYP. 7
16
ZC 0417
15
TYP.7
14
14 13 12
MA 0003 A
MA 0003 B
NOTE 2
NOTE 2
13 12
11
11
10
10
9
9
TI 0131
8
1-1/2"-DIE-011025004-103CS1P-P
8 7 6 5
6"-DIE-011043001-103CS1P-P
4 3 2 1
5
6"-DIE-011025001-103CS1P-P
LIGHT GASOIL TO 011-E-0034
4233
4
1
LIGHT GASOIL
FROM 011-E-0024
TO LPT 011-A-0004
DS011-TRJR-480110 3269
DS011-TRJR-480061 6962
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001).
NOTE 6
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / FBL
RDP/MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
IRG / FCB
RDP/MAC
JAL
PREPARED BY
CHECKED BY
REV
COMPANY STATUS
DATE
UTILITIES IDENTIFICATION POS.
1 2 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEM SHALL BE GRAVITY FLOW DESIGNED. 3 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 4 5 6 7 NOTES 8 1- MAKE CONNECTION ON TOP OF PIPE. 9 2- VIBRATION TRIP IS REQUIRED FOR EACH MOTOR AS PER MOTOR TYPICAL. 10 3- 1% SLOPE IN LAST PASS OF TUBE BUNDLE IS TO BE CONSIDERED. 11 4- AIR COOLER HAS 1BAY WITH 2 MOTORS/FANS EACH AND 2 BUNDLES PER BAY. 12 5- SHUTDOWN PROTECTION DEVICES 2 ACCELEROMETERS SHALL BE PROVIDED. 13 14 6- OP. TEMP ºC IN/OUT: 107.6/65. 15 16 17 18
2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-480022.
m² barg °C barg °C Gcal/h
2"
2
LAGO
011-A-0003-A/B FORCED 336.0 10.40 107.60 20.00 140.00 3.03
6
3
GENERAL NOTES
AIRFINS TYPE SURFACE OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP DUTY
7
TT 0131
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 KERO - LAGO - HAGO PRODUCTS COOLERS
011-074 011-076 011-075 011-080
Item Tags :
011-A-0003A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480059.pid
Discipline: PRO
SA-JER-DS011-TRJR-480059 2271-011-PID-0021-025
REV:
05
Sheet: 2 of 5
SCALE: NONE Format:
A1
41
41
011-E-0034 LAGO TRIM COOLER
40
40
INSULATION SHELL/TUBE: P/N 39
39
6"-DIE-011025001-103CS1P-P
38
38
1"D2" 15.40
37
37
+
36
36
TZV 0011 +
35
35
2"-CWR-011025002-101CS1P-N CL300
34
34
2"x1" 3/4"
MIN.
33 32
FB LO NOTE 3
NOTE 4 UG 301FE0W
31 30 3
33
D
AG 101CS1P MIN.
TI 0322
31
2"-CWR-011025305-101CS1P-N 2"
30
6"-CWR-011025302-101CS1P-N
6"-CWR-011072304-301FE0W-N
011-E-0034
CL300
4713
29
32
3/4" D
8"x6" 29
6"
8"
B1
28 27
A1
6"
26 3
27
B2
8" 26
MIN.
25
8"x6" MIN.
6"-CWS-011025302-101CS1P-N
LPT 2"
4714
3/4" D
24
28
A2
TT 0323
TI 0323
25
H
24
1/2" 23
MIN.
22
FC
0140
0140
2"x3/4"
19
2"
250mm MIN.
103CS1P 101CH2S
18
2"-CLD-011025315-101CH2S-P 17
22 21
FY 0030
6"-DIE-011025002-103CS1P-N
MIN.
D
20
23
1/2"
3/4"
3/4"-DIE-011025010-103CS1P-N 21
FT
RATIO FY 0140
20
LIC RATIO
19
0325
18
FY 0119
17
16
16 25 2549
15
15
FT 0119
14
14
FC 1/2"
13
1/2"
FV 0119 +
+
7
4"
6"x4"
NC NOTE 7 TYPE 5 SC
6 5
011-SC-0003
3/4"-DIE-011025007-103CS1P-N
LIGHT GASOIL 4233 FROM 011-A-0003
2"
6"x4"
PIPING INST.
2"-CLD-011025303-101CH2S-P
103CS1P 101CH2S 2"-CLD-011025304-101CH2S-P
AT
5063
SIGNAL
AI 0025 A
DS011-TRJR-480133 5406
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1, 2, 5 DELETED. 3- GATE VALVE SHALL BE INTALLED WITH STEM IN OR BELOW THE HORIZONTAL POSITION. 4- AL GRADE. AT SAFE LOCATION. 6- LOCATED IN SHELTER ANALYZER 011-AS-0001. SEE P&ID Nº SA-JER-DS011-TRJR-480289. 7- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS11-TRJR-480274. 8- H.V.@ 150ºC. SHELL SIDE.
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-E-0034 AES 9.70 5.50 65.00 36.50 50.00 46.50 20.00 15.40 108.00 80.00 147.6 0.98
NOTE 8
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
8 7 6 5 4 3 SIGNAL
LAGO
TO B.L.
FROM 011-G-0020
TO LP HDS
DS011-TRJR-480087 3277
DS011-TRJR-480133 3282
2
DS011-TRJR-480135 6970
1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MVF / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
FROM B.L.
DS011-TRJR-480133 3275
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
2"-PRO-011033008-103CH2S-N
5064
95% ASTM D86 LAGO
D
25
0025
TO SLOP/STORAGE
3/4"
D
RECOVERED OIL
25
NOTE 6
3/4"
3/4"-DIE-011025011-103CS1P-N
D
103CS1P 103CH2S
MIN.
2"x3/4"
9
MIN.
6"x4"
OVERRIDE
MIN.
103CS1P 101CH2S
250mm MIN.
1
RETURN SAMPLE LINE
6"-DIE-011025002-103CS1P-N
2
4" NC
3/4" 3/4"-DIE-011025005-103CS1P-N 2"x3/4"
MIN.
MIN.
2"-DIE-011025014-103CS1P-N
MIN.
3
10
3/4"
2" 6"x4"
11
6"-DIE-011025015-103CS1P-N
PIPING INSTR.
MIN.
V
FC CL300
12
6"x4"
FC CL300
SAMPLE LINE
8
4" 6"x4"
3/4"-DIE-011025006-103CS1P-N
9
6"x4"
MIN.
10
6"x4" 4"
6"-DIE-011025015-103CS1P-N
6"-DIE-011025001-103CS1P-P
11
4
0119
FT 0030
MIN.
FV 0030
12
FC 0030
250mm MIN.
13
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 LAGO PRODUCTS COOLERS ORIGINAL SIGNED IN PROJECT FILE
Item Tags : 011-E-0034
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480060 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480060 2271-011-PID-0021-025
REV: 05
Sheet: 3 of 5
SCALE: NONE Format:
A1
41
41
011-A-0004 HAGO COOLER
40
40
39
39
HPT 3/4"-LFL-011025303-101CH2F-N
38
A/B
37 36
NOTE 3
37
101CH2F 103CS1P
NC
36 35
MIN.
35
38
29 6186
3/4"
34
3/4"-HFO-011025011-103CS1P-P
V
34 33
32
32
MIN.
33
6"-HFO-011001001-103CS1P-P 31
31
HPT
30
30
29
29
28
28
27
27
6"
26 25
6"
011-A-0004A
24 23
25
NOTES 4,5
6"
26
6"
N1
N1
N2
N2
6"
011-A-0004B
24 23
6" N4
22
D
21
1-1/2"
21
M
M
MCC
MCC
20 19
22
TYP.7
20
ZC 0412
NOTE 4
19
TYP.7
18
18
17
17
16 15 14
MA
MA
0004 A
0004 B
NOTE 6
NOTE 6
6"
16 15 14
6"
13
13
TI
12
12
0132
11
11
10
10
1-1/2"-HFO-011025012-103CS1P-P
TT
9 8 7 6 5
0132 9
2" 6"-HFO-011025001-103CS1P-P
HEAVY GASOIL TO 011-E-0035
8 4145
7 6 5
103CS1P 101CS1P
1-1/2"-DIE-011025004-103CS1P-P 4
1-1/2"-HFO-011025012-103CS1P-P
4 3
MIN.
3 2
2
3/4"-OLW-011025302-101CS1P-N 6"-HFO-011001001-103CS1P-P
2"x1-1/2"
1
103CS1P 101CH2S
250mm MIN.
1
2"-CLD-011025316-101CH2S-P
HAGO FROM 011-E-0002
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
25
03
2825
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
LIGHT GASOIL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
RDP / MAC
JAL
FROM 011-A-0003 DRAIN
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
IRG / JLM
RDP / MAC
JAL
OLW
DS011-TRJR-480059 6962
DS011-TRJR-480003 2796
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEM SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1- OP. TEMP. IN / OUT : 96ºC / 65 ºC
AIRFINS TYPE SURFACE OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP DUTY
m² barg °C barg °C Gcal/h
011-A-0004 A/B FORCED 264.0 10.10 96.00 20.00 130.00 1.85
2- AIR COOLER HAS 1 BAY WITH 2 MOTORS / FANS EACH AND 2 BUNDLE PER BAY. 3- CONNECTION ON TOP OF PIPE. 4- SHUTDOWN PROTECTION DEVICES 2 ACCELEROMETERS HAS BEEN PROVIDED. 5- 1% SLOPE IN LAST PASS OF TUBE BUNDLE HAS BEEN CONSIDERED. 6- VIBRATION TRIP IS REQUIRED FOR EACH MOTOR AS PER MOTOR TYPICAL.
NOTE 1
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 HAGO PRODUCTS COOLERS ORIGINAL SIGNED IN PROJECT FILE
Item Tags : 011-A-0004
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480061 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480061 2271-011-PID-0021-025
REV: 05
Sheet: 4 of 5
SCALE: NONE Format:
A1
41
41
011-E-0035 HAGO TRIM COOLER
40
40
INSULATION ( SHELL / TUBE ): P / N
39
39
38
38
37
37
6"-HFO-011025001-103CS1P-P 36
36
1"D2" 15.40 +
35
35
TZV 0012 +
34
2"-CWR-011025003-101CS1P-N
33 32
MIN.
NOTE 8
31
FB LO
34
CL300 2"x1"
33
3/4"
32
D NOTE 3
TI
31
0324 2"-CWR-011025306-101CS1P-N
30
MIN.
CL300
1-1/2"G3" 18.75 +
B1
PZV 0068 B
6"
011-E-0035
+
A2
3/4" V
27
LO FB
4"x3"
4"-LFL-011025304-101CH2F-N
26
A1
6"
24
MIN.
3
23
6"-CWS-011025303-101CS1P-N
V LPT
4712
3/4" 3/4" D
22
MIN. 3/4"
20
103CS1P 101CH2S
19
2"
18
2"-CLD-011025305-101CH2S-P 17
D
250mm MIN.
MIN.
3/4"-HFO-011025005-103CS1P-N 2"x3/4"
21
26
2140
NOTE 6
25
1-1/2"G3" NOTE 10 18.75
3/4"
MIN.
29
NOTE 5
4"x1-1/2"
6"
+
4"-HFO-011025004-103CS1P-N
25
NOTE 3
B2
0.2 %
FB LO
PZV 0068 A +
24
3/4" 4"x3"
V 23
FB NOTE 3 LO
4"x1-1/2"
NC
22
101CH2F 103CS1P
21
3/4" 3/4"
V NOTE 3
NOTE 3 011-SP-0036
20
V
FB LC
FT 0120
2" 1/2"
1/2"
+
PIPING
2548
6"x4"
6"-HFO-011025002-103CS1P-N
MIN.
16
2" 15
TI
17
6"x4"
FC
16
3/4"
2"
6"
011-SC-0020
H
14 13
SC
TYPE 5 MIN.
3/4"-HFO-011025007-103CS1P-N
0325
3/4"-HFO-011025008-103CS1P-N
NOTE 9 3/4"-HFO-011025006-103CS1P-N
SAMPLE LINE
11 10 9
3/4"
2"x3/4"
103CS1P 101CH2S
2"
8
2"-CLD-011025306-101CH2S-P 7
D
12 11 10
8
5066
NOTE 7
AT 5
0026
HEAVY GASOIL
95% ASTM D86
4145FROM 011-A-0004
7 6 5 4
AI 0026 A
3
3
2 1
SIGNAL TO B.L.
DS011-TRJR-480135 6975
05
13-MAR-2013
AB
04
30-SEP-2011
03
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-E-0035 AES 9.10 6.00 65.00 36.50 50.00 46.50 20.00 15.40 100.00 80.00 178.1 0.85 .
1, 2, 4 DELETED 3- GATE VALVE SHALL BE INSTALLED WITH STEM IN OR BELOW THE HORIZONTAL POSITION. 5- MECHANICAL LINK. 6- MAKE CONNECTION ON TOP OF PIPE. 7- ANALIZER LOCATED IN ANALIZER SHELTER 011-AS-0002. SEE P&ID SA-JER-DS011-TRJR-480290. 8- AT GRADE AT SAFE LOCATION. 9- FOR FURTHER INFORMATION SEE SAMBPLE DETAILS DIAGRAM: SA-JER-DS011-TRJR-480274. 10- SET PRESSURE READJUSTED BASED ON ELEVATION FROM TOP OF PIPE TO PZV. ELEVATION DIFFERENCE SHOULD NOT BE HIGHER THAN 14,7m. 11- HV.@150ºC SHELL SIDE. 12- TO BE CLOSED DURING VDU BYPASS OPERATION.
NOTE 11
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
HAGO TO B.L.
DS011-TRJR-480136 3285
DS011-TRJR-480132 3286
2 1
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / FBL
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MVF / FCB
RDP / MAC
JAL
PREPARED BY
CHECKED BY
DATE
UTILITIES IDENTIFICATION POS.
HAGO TO SLOP 011-E-0037
AB: AS BUILT
REV
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
9
NOTE 12
25
6
4
15
PIPING INST.
NC
13 12
4"
3/4"
2"
PIPING INST.
TT 0325
14
18
FV 0120
INST.
25
19
FC 0120
6"-DIE-011025003-103CS1P-N
6"
27
28
6"-HFO-011025002-103CS1P-N
28
RETURN SAMPLE LINE
UG AG 3/4" D 301FE0W 101CS1P
MIN.
4711
29
NOTE 10
250mm MIN.
3
2" 6"-CWR-011025303-101CS1P-N
6"-CWR-011072305-301FE0W-N
MIN.
29
30
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
Item Tags : 011-E-0035
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 HAGO PRODUCTS COOLERS ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480062 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480062 2271-011-PID-0021-025
REV: 05
Sheet: 5 of 5
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
37
36
36
35
35
34
34
33
33
32
32
31
31
30
30
29
29
28
28
27
27
16"-JET-011026001-101CS1P-H 26
26
25
25
24
24
23
23
22
22
21
21
24"x18"
18"-JET-011018001-101CS1P-H
20
20
24"x18"
NOTE 2
12 11 10
INST.
PI
16"-JET-011026001-101CS1P-H
0199
PI
NOTE 1 18"x14"
8
3/4"
16"x12" CL300
MIN. 2"
/4" 2"x3
CL600
M
13 12
PI 0058
11
3/4" 3/4"
16"x12"
CL300
CL300
2"
/4" 2"x3
CL600
M
2"-JET-011026006-101CS1P-P
9
3/4" 3/4"
2"-JET-011026007-101CS1P-P MIN.
5
ZC 0349
14
10
3/4"
NOTE 1 18"x14"
3/4"
6
15
NOTE 6
PIPING 3/4"
CL300
MIN.
9
16
PIPING INST.
011-G-0008-B
INST. 3/4"
PIPING
3/4"
0057
NOTE 6
PIPING 3/4"
16"-JET-011026005-101CS1P-H
0202
PI
011-G-0008-A
INST.
17
1/2"
PIPING INST. 3/4"
INST.
7
PIPING 1/2"
NOTE 5
NOTE 2
MIN.
13
NOTE 5
3/4"
MIN.
18"-JET-011026003-101CS1P-H
14
NC
UC
MCC
MIN. NOTE 4
ZC 0349
MCC
NOTE 4
4
MG 0008 A 24"-JET-011018001-101CS1P-H
2 1
KEROSENE PA
101CS1P 101CH2S
3/4"-OLW-011026301-101CS1P-N
2"-CLD-011026301-101CH2S-P
TYP. 6
NOTE 7
MIN.
NOTE 7
0310 MG 0008 B
OLW
101CS1P 101CH2S
250mm MIN.
TYP. 6
MIN.
0310
3
ZC
250mm MIN.
ZC
2"-CLD-011026302-101CH2S-P
25
25
3073
3075
KEROSENE REFLUX DS011-TRJR-480043 3237
30-SEP-2011
011-G-0008-A / B KERO PUMPAROUND PUMPS
03
INSULATION: H
FROM 011-C-0002 DS011-TRJR-480052 3258
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
m³/h barg bar barg °C kg/m³
011-G-0008-A / B CENTRIFUGAL 1310.0 8.40 2.79 12.50 170.00 656.0
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
011-071 011-071 011-071 011-071 011-071 011-074 011-074
KEROSENE PA TO 011-E-0007
2
DS011-TRJR-480008 2877
1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MVF / JLM
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION 19 20 21 22 23 24 25 26 27 28 29 30 31 32
4
OLW
04
011-073 011-072 011-073 011-071
5
TO 011-C-0002
AB
REF. DWG POS.
6
3
13-MAR-2013
GENERAL NOTES
7
3/4"-OLW-011026302-101CS1P-N
05
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER 4 POTABLE WATER 5 DEMI WATER NOTES 6 N.A. 1- PROVIDE A STRAIGTH LENGTH OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 7 N.A. 2- CHECK VALVE SHALL BE INSTALLED HORIZONTALY. 8 N.A. 3- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 9 HP STEAM 4- DISMOUNTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION. 10 MP STEAM 5- FLANGED GLOBE VALVE TYPE. 11 LP STEAM 6- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JER-DS011-TRJR-480252. 12 HP CONDENSATE 7- THIS MOTOR WILL INCLUDE A SOFTWARE TRIP PUSHBUTTON INSTEAD OF A HARD WIRED FROM MCR AUX. PANEL AS PER JERES-C-102 AND JERES-J-601. 13 MP CONDENSATE 14 LP CONDENSATE 15 BFW 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A.
8
16"-JET-011026001-101CS1P-H
3/4"
MIN.
2"
8"-JET-011026002-101CS1P-H
15
18
2"-JET-011026007-101CS1P-P
16
LPT
NOTE 3
MIN.
MIN.
UC
MIN.
18"-JET-011026004-101CS1P-H
LPT
2"
17
NOTE 3 2"-JET-011026006-101CS1P-P
18
MIN.
19
MIN.
19
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
Item Tags : 011-G-0008-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 KEROSENE PA PUMPS ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480063 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480063 2271-011-PID-0021-026
REV: 05
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
37
36
36
35
35
34
34
33
33
32
32
16"-DIE-011026003-103CS2P-H 31
31
30
30
26"x20" 29
29
26"x20" 28
20"-DIE-011018001-101CS2P-H
28 27 26 25 24
27 26 25 24
101CS2P 103CS2P
23
101CS2P 103CS2P LPT
2"
22
MIN.
UC
23
NOTE 3
LPT
2"
MIN.
UC
22
MIN.
MIN.
MIN.
MIN. 21
NOTE 3
3/4"
20
NC NOTE 7
21
NOTE 2
NOTE 7
3/4"
NOTE 2
20
14 13
INST. 12
PI 0214 PIPING
011-G-0010-A MIN.
3/4"
/4" 1"x3
MIN.
3/4"
M
INST.
3/4"
11
PI 0060
10 9 8
MIN. 3/4"
/4" 1"x3
2"
M
MIN.
ZC
3
26"-DIE-011018001-101CS2P-H
1
MG 0010 A
MCC
0350
TYP. 6 NOTE 9
ZC
NOTE 4
TYP. 6 NOTE 9
0309
103CS2P 101CH2S
3/4"-OLW-011026303-101CS1P-N
3/4"-OLW-011026304-101CS1P-N
103CS2P 101CH2S
0010 B
2"-CLD-011026304-101CH2S-P OLW
LAGO PA
25
3069
3071
INSULATION: H
05
13-MAR-2013
AB
LAGO PA TO 011-E-0013
2
DS011-TRJR-480018 2960
1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
AR
02
22-DIC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / STG
RDP/MAC
AR
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
RDP/MAC
JAL
00
11/DEC/09
IFD
IFD: ISSUE FOR DESIGN
MVF / FCB
RDP/MAC
JAL
REV
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 5,6 DELETED. 1- PROVIDE A STRAIGHT LENGTH OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 2- CHECK VALVE SHALL BE INSTALLED HORIZONTALLY. 3- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 4- DISMONTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION. 7- FLANGED GLOBE VALVE TYPE. 8- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JER-DS011-TRJR-480246. 9- THIS MOTOR WILL INCLUDE A SOFTWARE TRIP PUSHBUTTON INSTEAD OF A HARDWIRED FROM MCR AUX. PANEL AS PER JERES-C-102 AND JERES-J-601.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
4
TO 011-C-0002 DS011-TRJR-480044 3262
011-G-0010-A / B LAGO PUMPAROUND PUMPS
GENERAL NOTES
011-G-0010-A / B CENTRIFUGAL 1630.0 12.20 7.09 17.00 245.00 661.0
5
OLW
25
DS011-TRJR-480054 3261
6
3 LAGO REFLUX
MG
2"-CLD-011026303-101CH2S-P
FROM 011-C-0005
m³/h barg bar barg °C kg/m³
103CS2P 101CS1P
NOTE 4
MCC
0309
2
ZC
MIN.
0350
4
250mm MIN.
ZC
7
MIN.
5
MIN.
2"-DIE-011026007-103CS2P-P
103CS2P 101CS1P
2"-DIE-011026006-103CS2P-P
250 mm MIN.
6
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
12
16"x12"
NOTE 1 20"x16"
MIN. 2"
PIPING
NOTE 8
MIN.
MIN.
8
INST. PIPING
PIPING 1/2"
011-G-0010-B
16"x12"
NOTE 1 20"x16"
9
7
INST. PI 0217
PI 0059
15
13
PIPING
INST.
3/4"
NOTE 8
INST. PIPING 3/4"
10
16
14
1/2"
11
17
16"-DIE-011026003-103CS2P-H
15
18
8"-DIE-011026004-103CS2P-H
16
16"-DIE-011026005-103CS2P-H
20"-DIE-011026001-103CS2P-H
17
20"-DIE-011026002-103CS2P-H
16"-DIE-011026003-103CS2P-H
18
2"-DIE-011026007-103CS2P-P
19
2"-DIE-011026006-103CS2P-P
19
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
Item Tags : 011-G-0010-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 LAGO PA PUMPS ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480064 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480064 2271-011-PID-0021-026
REV: 05
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
37
36
36
35
35
34
34
33
33
32
32
18"-HFO-011027003-103CL2P-H
31
18"-HFO-011027005-103CL2P-H
31 30 29 28
26"x20"
20"-HFO-011018001-101CL2P-H
27
26"x20"
CLOSED
CLOSED
XLC 0022
XLS 0022 C
IA
XYV 0022
2"-FLO-011027301-101CS1P-N
UC
2"-HFO-011027001-103CL2P-H
16
3/4" D
LPT
11 10 9 8
3/4"
MIN.
INST. PIPING
NC
NOTE 8
PI 0061
18"x12"
12" 20"x14"
PIPING
3/4"
15
MIN.
INST.
PIPING
PIPING INST.
14"
16
LPT
MIN.
1/2"
011-G-0012-A
17
NOTE 3 NOTE 5 3/4" D
NOTE 2
3/4"
3/4"
XV 0024
3/4"
INST.
MIN.
6
6391
PI 0221
NOTE 1
7
FLO
0362
20"-HFO-011027001-103CL2P-H
12
19
+
NOTE 7
PI
3/4"
20
FC TSO
2" UC D
2"-FLO-011027306-101CS1P-N 2"-HFO-011027002-103CL2P-H
2"-HFO-011027006-103CL2P-P
INST.
PIPING
MIN.
13
ATM
+
NOTE 7
PI 0363
20"-HFO-011027002-103CL2P-H
14
NOTE 5
21
+
NOTE 3 101CS1P 103CL2P
2309
S
XV 0023
FLO
15
22
IA
18
MIN.
17
0024 C
XYV 0024
FC TSO
+
XV 0022
2"
0024
0302
101CL2P 103CL2P
XYV
+
+
XLS
UC
DE
DE
18
XV 0021
0302 FC TSO
+
24 23
XLC
NOTE 6 ATM
101CS1P 103CL2P
S
FC TSO
+
UC
ATM
0301
101CL2P 103CL2P
XLS 0023 C
NOTE 6
UC
ATM
25
XLS 0024 O
CLOSED
XLC 0023
IA
XYV 0021
19
0023 O
NOTE 6
UC 0301
20
0023
IA
NOTE 6
21
0022 O
DE
22
XLS 0021 C
0022
XLO 0024
3/4"
NOTE 2
PI 0222
INST.
PIPING
13 12 11
18"x14" 10
INST. PIPING
1/2"
3/4"
011-G-0012-B
3/4"
NOTE 8
9
3/4"
PI 0062
12" 18"x12" 14"
20"x14"
NOTE 1
14
PIPING INST.
MIN.
2"
3/4"
/4" 2"x3
M 3/4"
2"
" 3/4 2"x
M
5
3/4"-HFO-011027006-103CL2P-P
2"-HFO-011027007-103CL2P-P
MCC TYP. 6
NOTE 9
0308 103CL2P 101CH2S UC 0301
MG 0012 A
2"-CLD-011027301-101CH2S-P
3/4"-OLW-011027001-101CS1P-N
0351 ZC
3
MCC TYP. 6
HAGO REFLUX
NOTE 9
0308 103CL2P 101CH2S
UC
MG
0302
0012 B
2"-CLD-011027302-101CH2S-P
OLW
3/4"-OLW-011027002-101CS1P-N
OLW
011-G-0012-A / B HAGO PUMPAROUND PUMPS
3064 HAGO PA FROM 011-C-0002
3065
INSULATION: H
DS011-TRJR-480056 3274
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1- PROVIDE A STRAIGTH LENGTH OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 2- CHECK VALVE SHALL BE INSTALLED HORIZONTALLY. 3- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 4- DISMONTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION. 5- FOR THE FILLING PHASE.
m³/h barg bar barg °C kg/m³
011-G-0012-A / B CENTRIFUGAL 1612.0 13.20 8.89 18.50 309.00 665.0
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
6- CLOSING SUCTION OR DISCHARGE VALVE AUTOMATICALLY STOP ASSOCIATED PUMP (VIA DCS UC 0301/0302) IN CASE OF LOSS OF OPEN POSITION. 7- PROVIDE FLANGED 3/4" BYPASS WITH GLOBE VALVE AT THE CHECK VALVE / AUTOMATIC SPILL VALVE FOR PUMP WHICH HAS TO BE IN HOT STANDBY. 8- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JER-DS011-TRJR-480246. 9- THIS MOTOR WILL INCLUDE A SOFTWARE TRIP PUSHBUTTON INSTEAD OF A HARDWIRED FROM AUX. PANEL FROM MCR AUX. PANEL AS PER JERES-C-102 AND JERES-J-601. 10- DELETED.
05
13-MAR-2013
AB
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
HAGO PA TO NAPHTHA SPLITER REBOILER DS011-TRJR-480134 3288
2 1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUE FOR DESIGN
MMG / FBL
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS.
TO 011-C-0002 DS011-TRJR-480044 3268
25
25
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
5
NOTE 4 MIN.
ZC
ZC
NOTE 4
250mm MIN.
1
6
250mm MIN.
0351
26"-HFO-011018001-101CL2P-H
2
7
MIN.
103CL2P 101CS1P
ZC
MIN.
3
8
4
MIN.
103CL2P 101CS1P
4
14"-HFO-011027003-103CL2P-H
XLC 0021
XLS
10"-HFO-011027004-103CL2P-H
CLOSED
23
XLO
2"-HFO-011027007-103CL2P-P
0021 O
XLS
MIN.
0021
27
DE
XLS
28
OPEN
XLO
S
24
XLO
OPEN
OPEN
S
OPEN
25
29
26
20"-HFO-011018001-101CL2P-H
26
30
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 HAGO PA PUMPS
011-074 011-076 Item Tags :
011-075 011-080 011-077
011-G-0012 A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480065.pid
Discipline: PRO
SA-JER-DS011-TRJR-480065 2271-011-PID-0021-027
REV:
05
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
40
40
39
39
1"-HFO-011027111-103CL4P-S
38
1"-HFO-011027110-103CL4P-S
SC
38
FC
011-SC-0043 TYPE 15 NOTE 10
37 36
37
0032 A FT 0032 A
RO 0006 +
36
35 34
1/2"
1/2"
1/2"
1/2"
35
INST. PIPING
34
33
33
MIN.
32
MIN.
12"-HFO-011027103-103CL4P-S 32
D
1"
31
31
XLC 0027
MIN.
25
MIN.
6214
INST. PI 0366
PIPING 1"
1"
FLO 2310
18"-HFO-011027101-103CL4P-S
11 10 9 8
H
PDI 0035
1"
NC
NOTES 2,7 INST. PIPING
+
NOTE 3 INST.
1"
1"-HFO-011027107-103CL4P-S
1"
1"
1"
1" 12"x10" NOTE 118"x14"
7
1"
PIPING INST.
PI 0063
H
M
2"
INST.
0065 1"
1"
1"
1"
1"
1"
PI 0064
12"x10"
011-G-0014-B
NOTE 9
3/4"
M
2"
NOTE 9
MIN.
MIN.
1"
2"x1"
103CL4P 101CH2S 2"-CLD-011027305-101CH2S-P
MG 0014 A
103CL4P 101CH2S
0342
1"-OLW-011027303-101CS1P-N
ZC
2"-CLD-011027303-101CH2S-P
25 3062
TYP. 6
0302
103CL4P 101CH2S
MG 0014 B
2"-CLD-011027304-101CH2S-P
OLW
1"-OLW-011027304-101CS1P-N
4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 8 DELETED. 1- PROVIDE A STRAIGTH LENGTH OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 2- CHECK VALVE SHALL BE INSTALLED HORIZONTALY. 3- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 4- DISMONTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION. 5- ISOLATION PROVIDED IN CASE OF VDU SHUTDOWN. PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
m³/h barg bar barg °C kg/m³
011-G-0014-A / B CENTRIFUGAL 1000.0 14.90 11.69 21.70 354.00 806.0
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
6- CLOSING SUCTION OR DISCHARGE VALVE AUTOMATICALLY STOP ASSOCIATED PUMP (VIA DCS UC 0309/0310). IN CASE OF LOSS OF OPEN POSITION. 7- PROVIDE FLANGED 1" BYPASS WITH GLOBE VALVE AT THE CHECK VALVE/AUTOMATIC SPILL VALVE FOR PUMP WHICH HAS TO BE IN HOT STANDBY. 9- FOR FORTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JER-DS011-TRJR-480247. 10- FOR FURTHER INFORMATION SEE SAMPLE COLLECTOR DETAILS DIAGRAM: SA-JER-DS011-TRJR-480273. 11- PROVIDE WITH HECHANICAL TRAVEL STOP AT 110% NORMAL CV. 12- DELETED.
5 4 3
VAC RESIDUE
25
TO 011-F-0002
DS011-TRJR-480044 3281
DS011-TRJR-480103 3293
DS011-TRJR-480103 3294
7676
DS011-TRJR-480312 5555
05
13-MAR-2013
AB
ATM RESIDUE
2 1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MSS / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MMG / JLM
RDP / MAC
JAL
REV
DATE
UTILITIES IDENTIFICATION 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
6
FROM 011-G-0018
DS011-TRJR-480044 3280
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED.
7
ATM RESIDUE
FROM 011-C-0002
POS.
9
TO 011-E-0020
3063
GENERAL NOTES
10
ATM RESIDUE
INSULATION: S
ATM RESIDUE
11
1"
TO 011-C-0002
OLW
25
011-G-0014-A / B ATM RESIDUE PUMPS
MIN.
103CL4P 101CH2S
5067
MCC 101CS1P
20"-HFO-011018101-103CL4P-S
0302
0310
103CL4P
TYP. 6
ZC
MIN.
ZC 1
MCC
UC
12
8
25
NOTE 4
13
250mm MIN.
0342
103CL4P 101CS1P
0309
NOTE 4 MIN.
ZC
MIN.
250mm MIN.
2
UC
MIN.
1"-HFO-011027112-103CL4P-S
2"-HFO-011027108-103CL4P-S
2"-HFO-011027107-103CL4P-S
3
FO 14
PIPING
PIPING INST.
17 16
1"-HFO-011027108-103CL4P-S
PDT
18
15
HV 0020
5 4
0020
FO NOTE 11
1"x1/2"
011-G-0014-A 3/4"
NOTES 2, 7
1"
0065
NOTE 1 18"x14"
6
8"x6"
HC
1" PDI
PDT
1"
6"
25 7673
+
1"x1/2" 0035
MIN.
PIPING 1"
PI 0367
8"x6"
19
9408
1"-HFO-011027124-103CL4P-S
MIN.
FV 0032
20
25
D
1"
21
2"-CLD-011027309-101CH2S-P
DE
2"-FLO-011027303-101CS1P-N
UC
NOTE 3
13 12
2312
2"
SHORT RECIRCULATION
14
FLO
+
10"-HFO-011039104-103CL4P-S
15
2"-HFO-011027102-103CL4P-S
XV 0028
22
10"x6"
16
1" D
4"-CLD-011027306-101CH2S-P
+
6"
17
+
XYV 0028
10"x6"
2"-FLO-011027302-101CS1P-N
UC
+
FC TSO
XV 0027
FC TSO
VDU BY PASS
2"
XV 0026
+
18"-HFO-011027102-103CL4P-S
18
2"-HFO-011027101-103CL4P-S
XYV 0027
+
2"-HFO-011027107-103CL4P-S
19
XYV 0026
ATM
103CL4P 101CH2S
103CL4P 101CH2S
12"-HFO-011027105-103CL4P-S
101CS1P 103CL4P
+
0309
103CL4P 101CH2S
ATM
UC 0310
24 23
8"-HFO-011027114-101CL4P-S
XV 0025
FC TSO
UC 0310
2"x1"
NOTE 6
2"-CLD-011027308-101CH2S-P
FC TSO
+
IA
103CL4P 101CL4P
XYV 0025
20
MIN.
DE
S
21
ATM
UC
XLC 0028
S
103CL4P 101CH2S
ATM
1"
NOTE 6
NOTE 6 S
UC 0309
4"-CLD-011027306-101CH2S-P
22
XLS 0028 C
IA
MIN.
NOTE 6
IA
MIN.
MIN.
1"
IA
XLS 0027 C
25
12"-HFO-011027103-103CL4P-S
XLC 0026
XLS 0026 C
250mm MIN.
MIN.
MIN.
23
XLS 0025 C
2"-HFO-011027108-103CL4P-S
XLC 0025
250 mm MIN.
24
CLOSED
1" D
26
1" D MIN.
CLOSED
0028
MIN.
250 mm MIN.
CLOSED
CLOSED
0028 O
MIN.
27
MIN.
0027 O
MIN.
28
2"-CLD-011027310-101CH2S-P
0027
1"-HFO-011027123-103CL4P-S
250 mm MIN.
0026
MIN.
2"x1"
0026 O
XLS
OPEN XLO
8"-HFO-011027104-103CL4P-S
XLS
MIN. 4"-HFO-011027122-103CL4P-S
DE
0025 O
XLS
OPEN XLO
FI 0032 B L
29
MIN.
0025
LPT
OPEN XLO
MIN. 4"-HFO-011027121-103CL4P-S
FT 0032 B
MIN.
XLS
LPT
250 mm MIN.
25
OPEN XLO
DE
26
18"-HFO-011018101-103CL4P-S
S
27
20"x18"
20"x18"
101CS1P 103CL4P
28
12"-HFO-011027106-103CL4P-S
29
30
NOTE 5 MIN.
PIIPING INST.
250 mm MIN.
1/2"
1"-HFO-011027132-103CL4P-S
1/2"
2"x1"
1/2"
MIN.
30
1/2"
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080 011-077
Item Tags : 011-G-0014-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 ATM RESIDUE PUMPS ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480066 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480066 2271-011-PID-0021-027
REV: 05
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
41
8"-MPS-011028002-103CS1P-H
40 39
DILUTION STEAM FROM 011-D-0019
39
FMC
EMERGENCY STEAM FROM HEADER
10"-MPS-011028301-103CS1P-H
FC
38
0034 B
+
33
PASS 2
1/2"
1/2"
MIN.
1/2"
FV 0034 B 4"
6"x4"
6"-HFO-011027103-103CL4P-S
1/2" 1/2"
1/2"
1/2"
1/2" 1/2"
1/2"
1/2"
29
25
2oo3 FI 0034 B LL
24
ZC
0336
0334
29
8"x3"
NC
FMC
FC 0036 B
1"-HFO-011028102-103CL4P-S
1"
0034 BC
ZC
ZC 0337
27
2"x1"
FT
103CL4P 101CH2S
0036 B
2"-CLD-011028302-101CH2S-P
1/2"
INST. PIPING
1/2"
FV 0036 B +
22
25
3"-MPS-011028005-103CS1P-H
PASS 2
32
28
FT
23
8"-HFO-011028109-103CL4P-S
31
3"
MIN.
MIN.
26
8"x4"
FO
6"x3"
250mm MIN.
27
33
MIN.
30
FT 0034 BB
8"-MPS-011028002-103CS1P-H
28
INST. PIPING
31 30
34
LO
+
MIN.
32
1/2"
35
6"-HFO-011028109-103CL4P-S
25 24 23 22
1-1/2" 3"x1-1/2"
3"x1-1/2"
5069
26
6"-MPS-011028303-103CS1P-H
FY 0034 B
FY 0036 B
INST. PIPING
36
103CS1P 103CL4P
REV
FT 0034 BA
34
21
21
FO 3/4"
8"x3"
D
20
ZC 1/2"
0337
19
0034 A
17
L
FI 0037 B
1/2"
1/2"
1/2"
1/2"
INST. PIPING
1/2"
1/2" 1/2"
1/2"
1/2"
FT
6"x3"
13 12
3"
8"x3"
MIN. 250mm MIN.
FI 0034 A LL
4
ZC 0334
1"
FC 0036 A
1"-HFO-011028101-103CL4P-S
103CL4P 101CH2S
FT 0036 A
2"-CLD-011028301-101CH2S-P
ZC 0336
1/2"
1/2"
DS011-TRJR-480312
DS011-TRJR-480071
5554
5422
FROM 011-G-0014-A/B
FROM 011-G-0014-A/B
DS011-TRJR-480312 5563
DS011-TRJR-480312 5562
3"x1-1/2"
3
1-1/2" 3"x1-1/2"
PIPING INST.
3"-MPS-011028002-103CS1P-H
1/2"
D
3"x1-1/2" 1-1/2" 3"x1-1/2" NC
FT 0037 A
SIGNAL FROM TY-0140 A
DS011-TRJR-480072
DS011-TRJR-480071
DS011-TRJR-480312
DS011-TRJR-480312
5600
5424
5553
5550
FI
DILUTION STEAM
0037 A
TO 011-F-0002
L
DS011-TRJR-480071 3297
05
13-MAR-2013
AB
04
30-SEP-2011
03
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 1,2,3 DELETED.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
DILUTION STEAM
ATM RESIDUE
TO 011-F-0002
TO 011-F-0002
DS011-TRJR-480071 3298
DS011-TRJR-480072 3295
DS011-TRJR-480072 3296
2 1
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
NPS / FCB
RDP / MAC
JAL
PREPARED BY
CHECKED BY
DATE
UTILITIES IDENTIFICATION POS.
ATM RESIDUE TO 011-F-0002
AB: AS BUILT
REV
NOTES
5
FV 0036 A
5068
1/2"
SIGNAL TO FY-0033 A
6
4
3/4"
SIGNAL TO TY-0140 AA
7
INST. PIPING
FO
SIGNAL FROM TY-0140 B
8
+
6"-HFO-011027113-103CL4P-S
6"-HFO-011027103-103CL4P-S
3"-MPS-011028002-103CS1P-H
ZC 0337
2"x1"
25
PASS 1
FMC
8"-HFO-011028109-103CL4P-S
NC
MIN.
2oo3
3
8"x4"
10
FT 0034 AC
5
4"
14
MIN.
9
8
6
15
11
0034 AB
7
FY
16
6"-HFO-011027113-103CL4P-S
FO
MIN. 1/2"
INST. PIPING
1/2" 1/2"
9
L
+
10
ATM RESIDUE
18
LO REV
FV 0034 A 6"x4"
11
ATM RESIDUE
103CS1P 103CL4P
NC
0036 A
12
SIGNAL TO TY-0140 AA
19
17
PASS 1
SIGNAL TO FY-0033 A
+
3"-MPS-011028005-103CS1P-H
14
1
RO 0003
3"x1-1/2"
MIN.
15
2
1-1/2"
FT 0037 B
0034 AA
0034 A
13
3"x1-1/2"
FT
FY 16
PIPING INST.
FMC
FC 18
1/2"
8"-HFO-011027113-103CL4P-S
20
38 37
10"-MPS-011028301-103CS1P-H
RO 0004
ZC 0337
35
4174
L
37 36
40 4172
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 011-075 011-080
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM HEATER INLET ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480067.pid
Discipline: PRO
SA-JER-DS011-TRJR-480067 2271-011-PID-0021-028
REV:
05
Sheet: 1 of 5
SCALE: NONE Format:
A1
41
41
DILUTION STEAM 4172 TO PASS 1 AND 2 EMERGENCY STEAM 39 4174 TO PASS 1 AND 2 40
8"-MPS-011028002-103CS1P-H
8"-MPS-011028002-103CS1P-H
DILUTION STEAM FROM 011-D-0019
10"-MPS-011028301-103CS1P-H
10"-MPS-011028301-103CS1P-H
40 4253
EMERGENCY STEAM 39 4256 FROM HEADER
FMC FC 0034 C
36
6"-MPS-011028306-103CS1P-H L
ZC
31
PASS 3
1/2"
1/2"
1/2"
1/2"
INST. PIPING FV 0034 C 4"
6"x4"
6"-HFO-011027115-103CL4P-S
30
1/2"
1/2"
1/2"
1/2"
1/2"
1/2"
29
33
MIN.
8"x4"
32
FO
31 30 29
6"x3"
FT 28
8"x3"
3"
0034 CB FT 0034 CC
27
NC
MIN.
FMC
1"-HFO-011028103-103CL4P-S
1"
FC 0036 C
2oo3 FI 0034 C
ZC 0334
FT
103CL4P 101CH2S
250mm MIN.
24
ZC 0336
0036 C
27 26 25
INST. 1/2"
PIPING
1/2"
23
FV 0036 C +
25
3"-MPS-011028006-103CS1P-H
28
24
2"-CLD-011028303-101CH2S-P
22
PASS 3
ZC 0337
LL
25
23
2"x1"
MIN.
26
34
LO
+
MIN.
32
0034 C
35
6"-HFO-011027115-103CL4P-S
INST. PIPING
33
FY
36
103CS1P 103CL4P
REV
FY 0036 C
1/2" 1/2"
34
3"-MPS-011028006-103CS1P-H
3"-MPS-011028009-103CS1P-H
35
+
0337
FT 0034 CA
37
RO 0036
MIN.
37
38
6"-MPS-011028308-103CS1P-H
38
3"x1-1/2"
5070
22
1-1/2" 3"x1-1/2"
21
21
FO 3/4"
20
ZC 0337
FMC
19
FC 0034 D
18
20
PIPING 1-1/2"
3"x1-1/2"
INST. FT 0037 C
L
RO 0037 +
3"x1-1/2"
19
103CS1P 103CL4P
NC
18 17
FT
FY 0034 D
16
1/2"
0034 DA
15
1/2"
1/2"
1/2"
1/2"
FI 0037 C
INST. PIPING
LO REV
L
FY 0036 D
FV 0034 D
16
MIN.
17
1/2"
D
6"-HFO-011027116-103CL4P-S
15
+
14
6"x4"
PASS 4
12
1/2"
1/2"
FT 0034 DB
8
10
6"x3"
2oo3
1"
250mm MIN.
LL
5 4
ZC 0334
3
8"x3"
NC 1"-HFO-011028104-103CL4P-S
2"x1"
FMC
FI 0034 D
6
3"
9
MIN. FT 0034 DC
7
11
MIN.
9
12
FC 0036 D
103CL4P 101CH2S
FT
2"-CLD-011028304-101CH2S-P
ZC 0336
ZC 0337
8"-HFO-011027115-103CL4P-S
10
13
3"-MPS-011028006-103CS1P-H
1/2"
8"x4"
8"-HFO-011027116-103CL4P-S
1/2"
INST. PIPING
11
4" FO
MIN.
13
14
MIN.
8 7 6 5
0036 D
1/2"
1/2"
4
INST. PIPING
FV 0036 D
3
+
25
PASS 4
1
5071
3"x1-1/2"
1-1/2" 3"x1-1/2" FO
6"-HFO-011027116-103CL4P-S
6"-HFO-011027115-103CL4P-S
3"-MPS-011028009-103CS1P-H
3/4" 1/2"
1/2"
PIPING INST.
3"-MPS-011028009-103CS1P-H
2
D
3"x1-1/2" 1-1/2" 3"x1-1/2"
FT
NC
0037 D
FI SIGNAL TO TY-0140 AA
SIGNAL TO FY-0033 A
DS011-TRJR-480071
DS011-TRJR-480312
5420
5551
ATM RESIDUE
ATM RESIDUE
FROM 011-G-0014-A/B
FROM 011-G-0014-A/B
DS011-TRJR-480312 5561
DS011-TRJR-480312 5560
SIGNAL FROM TY-0140 C
SIGNAL TO FY-0033 A
SIGNAL TO TY-0140 AA
SIGNAL FROM TY-0140 D
DS011-TRJR-480073
DS011-TRJR-480312
DS011-TRJR-480071
DS011-TRJR-480074
5582
5552
5426
5583
0037 D
DILUTION STEAM
L
05
13-MAR-2013
AB
04
30-SEP-2011
03
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DILUTION STEAM
ATM RESIDUE
TO 011-F-0002
TO 011-F-0002
DS011-TRJR-480074 3289
DS011-TRJR-480073 3291
DS011-TRJR-480073 3292
2 1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
NPS / FCB
RDP / MAC
JAL
TO 011-F-0002 DS011-TRJR-480074 3287
REV
GENERAL NOTES
ATM RESIDUE TO 011-F-0002
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080 011-077
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM HEATER INLET ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480068.pid
Discipline: PRO
SA-JER-DS011-TRJR-480068 2271-011-PID-0021-028
REV:
05
Sheet: 2 of 5
SCALE: NONE Format:
A1
41
41
40 4253
DILUTION STEAM TO PASS 1 TO 4
8"-MPS-011028002-103CS1P-H
EMERGENCY STEAM TO PASS 1 TO 2
10"-MPS-011028301-103CS1P-H
8"-MPS-011028002-103CS1P-H
39
FMC
FC 0034 E
6"-MPS-011028310-103CS1P-H +
ZC 0337
FT 0034 EA
31 30
PASS 5
FY 0036 E
1/2"
FV 0034 E 6"x4"
1/2"
1/2"
1/2"
1/2"
1/2"
1/2"
29
FT 0034 EB
4"
32
FO
6"x3"
3"
31
8"x3"
NC
MIN. 1"
1"-HFO-011028105-103CL4P-S FC
2"x1"
MIN.
FI
8"x4"
29
0034 EC 2oo3
ZC
0336
0334
103CL4P 101CH2S 2"-CLD-011028305-101CH2S-P
250mm MIN.
24
ZC
0337
0036 E
1/2"
1/2"
28 27 26 25 24
INST. PIPING
23
FV 0036 E +
22
25
PASS 5
ZC
FT
LL
23
FMC
0036 E
0034 E
25
33
MIN.
30
FT
27 26
34
LO
+
6"-HFO-011027117-103CL4P-S
28
35
6"-HFO-011027117-103CL4P-S
MIN.
1/2"
MIN.
32
1/2"
36
103CS1P 103CL4P
REV
INST. PIPING
1/2"
1/2" 1/2"
33
FY 0034 E
3"-MPS-011028007-103CS1P-H
3"-MPS-011028010-103CS1P-H
34
37
RO 0038
L
36 35
EMERGENCY STEAM 4262 FROM HEADER 38
6"-MPS-011028312-103CS1P-H
37
40 4260
39
10"-MPS-011028301-103CS1P-H
INST. PIPING
38 4256
DILUTION STEAM FROM 011-D-0019
3"-MPS-011028007-103CS1P-H
3"x1-1/2"
5021
21
22
1-1/2" 3"x1-1/2" 21
FO 3/4" D
ZC
20
0337 19
FC 0034 F
18
1/2"
1/2"
FMC
PIPING INST.
20
3"x1-1/2"
RO 0039 +
3"x1-1/2"
19
103CS1P 103CL4P
NC
FT 0037 E
L
1-1/2"
18
17
17
FY
14
1/2"
1/2"
1/2"
1/2"
1/2"
1/2"
1/2"
1/2"
1/2"
1/2"
10
6"x3"
LL
4
1"-HFO-011028106-103CL4P-S
SIGNAL TO TY-0140 BA
SIGNAL TO FY-0033 B
SIGNAL FROM TY-0140 E
DS011-TRJR-480075
DS011-TRJR-480312
DS011-TRJR-480075
5425
4192
4183
ZC 0334
ATM RESIDUE
FROM 011-G-0014-A/B
FROM 011-G-0014-A/B
DS011-TRJR-480312 5559
DS011-TRJR-480312 5558
103CL4P 101CH2S
FMC
ZC 0337
FT 0036 F
1/2"
3"x1-1/2"
1/2"
3
1-1/2" 3"x1-1/2"
1/2"
PIPING INST.
3"x1-1/2" 1-1/2" 3"x1-1/2" NC
FT 0037 F
TO TY-0140 BA
DS011-TRJR-480075
DS011-TRJR-480312
DS011-TRJR-480076
5423
4194
4187
FI 0037 F
DILUTION STEAM
05
13-MAR-2013
AB
04
30-SEP-2011
03
L
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DILUTION STEAM
ATM RESIDUE
TO 011-F-0002
TO 011-F-0002
DS011-TRJR-480076 3300
DS011-TRJR-480075 3302
DS011-TRJR-480075 3303
2 1
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
ARV / FCB
RDP / MAC
JAL
PREPARED BY
CHECKED BY
TO 011-F-0002
GENERAL NOTES
NOTES
ATM RESIDUE TO 011-F-0002
AB: AS BUILT
DS011-TRJR-480076 3299
REV
1,2, 3 DELETED.
5
+
3/4" D
SIGNAL FROM TY-0140 F
6
FV 0036 F
5022
SIGNAL TO FY-0033 B
7
4
FO
SIGNAL
8
INST. PIPING
25
6"-HFO-011027118-103CL4P-S
ATM RESIDUE
FC 0036 F
2"-CLD-011028306-101CH2S-P 1/2"
3"-MPS-011028010-103CS1P-H
6"-HFO-011027117-103CL4P-S
1
8"x3"
2"x1"
250mm MIN.
FI 0034 F
PASS 6
3"
1" MIN.
2oo3
2
12
NC
0034 FC
ZC 0336
13
10
MIN. FT
3
8"x4"
9
8
5
4"
14
MIN.
11
FT 0034 FB
6
15
FO
MIN. 1/2"
INST. PIPING
12
7
6"-HFO-011027118-103CL4P-S
+
6"x4"
9
FY 0036 F
FV 0034 F
6"-HFO-011027118-103CL4P-S
11
L
3"-MPS-011028010-103CS1P-H
PASS 6
13
1/2"
16
8"-HFO-011027117-103CL4P-S
0034 F
INST. PIPING
LO REV
3"-MPS-011028007-103CS1P-H
15
FI 0037 E
8"-HFO-011027118-103CL4P-S
16
MIN.
FT 0034 FA
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM HEATER INLET ORIGINAL SIGNED IN PROJECT FILE
Item Tags :
011-075 011-080
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480069.pid
Discipline: PRO
SA-JER-DS011-TRJR-480069 2271-011-PID-0021-028
REV:
05
Sheet: 3 of 5
SCALE: NONE Format:
A1
41
41
40 4260
DILUTION STEAM TO PASS 1 TO 6
8"-MPS-011028002-103CS1P-H
EMERGENCY STEAM TO PASS 1 TO 6
10"-MPS-011028301-103CS1P-H
40
39
38
FMC
FC 0034 G
6"-MPS-011028314-103CS1P-H L
FT 0034 GA FY
34
1/2"
1/2"
1/2"
1/2"
INST. PIPING
FY
29 28
6"x4"
4"
1/2"
1/2"
1/2"
31
3"
6"x3"
8"x3"
NC
1"
FT 0034 GC
1"-HFO-011028107-103CL4P-S
FI 25
32
29
MIN.
2oo3
26
8"x4"
30
FT 0034 GB
27
FMC
FC
2"x1"
0036 G
ZC 0337
0034 G
24 23 22
ZC
ZC
0336
0334
103CL4P 101CH2S
250mm MIN.
LL
FT
27 26 25 24
INST.
2"-CLD-011028307-101CH2S-P 1/2"
3"-MPS-011028008-103CS1P-H
28
0036 G
1/2"
23
FV 0036 G
PIPING
+
25
PASS 7
33
MIN.
FO
MIN. 1/2"
34
LO
+
MIN.
30
FV 0034 G
6"-HFO-011027119-103CL4P-S
35
6"-HFO-011027119-103CL4P-S
0036 G
INST. PIPING
31
PASS 7
3"-MPS-011028008-103CS1P-H
3"-MPS-011028011-103CS1P-H
32
103CS1P 103CL4P
REV
0034 G 33
36
+
MIN.
35
RO 0040
ZC 0337
36
37
6"-MPS-011028316-103CS1P-H
37
22
1-1/2" 3"x1-1/2"
3"x1-1/2"
5023
21
21
FO D
3/4"
20
ZC 0337
FT 0037 G
L
FT 0034 HA
FY 0034 H
1/2"
1/2"
1/2"
1/2"
0037 G
FV 0034 H +
1/2" 1/2"
1/2"
1/2"
1/2" 1/2"
1/2"
6"-HFO-011027120-103CL4P-S
MIN.
8"x4"
13 12
10
6"x3"
FT
MIN.
0034 HB
2oo3
8"x3"
NC 1"-HFO-011028108-103CL4P-S
MIN.
0034 HC
3"
1"
FT
FMC
FC
2"x1"
0036 H
ZC 0337
FI
6
LL
4 3
ZC
ZC
0334
0336
FT 0036 H
103CL4P 101CH2S
250mm MIN.
0034 H
5
2"-CLD-011028308-101CH2S-P 1/2"
1/2"
FV 0036 H
SIGNAL TO FY-0033B
DS011-TRJR-480075
DS011-TRJR-480312
6254
4196
3"x1-1/2"
3"-MPS-011028011-103CS1P-H
1-1/2" 3"x1-1/2" FO
6"-HFO-011027120-103CL4P-S
ATM RESIDUE
ATM RESIDUE
3/4" D 1/2"
1/2"
PIPING INST.
ATM RESIDUE
DILUTION STEAM
ATM RESIDUE
EMERGENCY STEAM
DILUTION STEAM
TO 011-F-0002
TO 011-F-0002
TO 011-F-0002
FROM HEADER
FROM 011-D-0019
DS011-TRJR-480078 3318
DS011-TRJR-480077 3319
DS011-TRJR-480077 3321
DS011-TRJR-480139 4528
DS011-TRJR-480139 4526
FROM 011-G-0014-A/B
FROM 011-G-0014-A/B
DS011-TRJR-480312 5557
DS011-TRJR-480312 5556
SIGNAL TO FY-0033 B
SIGNAL FROM TY-0140 H
DS011-TRJR-480077
DS011-TRJR-480075
DS011-TRJR-480312
DS011-TRJR-480078
5591
6253
4197
5590
0037 H L
DILUTION STEAM
1
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
NPS / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
TO 011-F-0002 DS011-TRJR-480078 3400
GENERAL NOTES
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
2
NC
0037 H
SIGNAL TO TY-0140 BA
5
3"x1-1/2" 1-1/2" 3"x1-1/2"
FT
SIGNAL FROM TY-0140 G
6
3
FI SIGNAL TO TY-0140 BA
7
+
3"-MPS-011028011-103CS1P-H 6"-HFO-011027119-103CL4P-S
1
8
4
5024
PASS 8
9
INST. PIPING
25
2
14
11
INST.
10
7
4"
15
FO
MIN. 1/2"
16
PIPING
12
8
L
LO
FY 0036 H
6"x4"
9
REV
PIPING
PASS 8
11
18 17
14 13
103CS1P 103CL4P
FI INST.
15
NC
8"-MPS-011028002-103CS1P-H
16
19
10"-MPS-011028301-103CS1P-H
17
+
8"-HFO-011027119-103CL4P-S
18
RO 0041
3"x1-1/2" 1-1/2" 3"x1-1/2"
INST.
FMC
20
PIPING
3"-MPS-011028008-103CS1P-H
FC 0034 H
1/2"
8"-HFO-011027120-103CL4P-S
19
1/2"
MIN.
38 4262
39
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM HEATER INLET ORIGINAL SIGNED IN PROJECT FILE
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480070.pid
Discipline: PRO
SA-JER-DS011-TRJR-480070 2271-011-PID-0021-028
REV:
05
Sheet: 4 of 5
SCALE: NONE Format:
A1
41
41
011-F-0002 VACUUM HEATER
40
40 SIGNAL
39
6235 39
FROM TC-0140 B
38
38 SIGNAL
6234 TO TC-0140 B
37
37
36
36
35
35
PI 0102 A
34
34
33
33
32
PI 0101 A
31 30
INST. PIPING
PT 0102 A
32
12"
STRIPPING STEAM FROM HEADER
16"
SEE DWG. DS011-TRJR-480079
STRIPPING STEAM TO 011-C-0003
31 30
1"
TI 0134 A
1"
29 28
8"x6"
PASS 1
H
TE NOTE 4 0134 A SKIN
29 28
V
6"x5"
5"-HFO-011029126-103CM4P-H
27
27
NOTE 2 26
TI 0136 A
25 24
H
26
SKIN NOTE 4 TE 0135 A
TE
ZC 0336
TI 0135 A
25 24
NOTE 4 0136 A SKIN
23
X
0334
22
23
TY 0140 AA
ZC
22
21
21
SP
20
TE 0137 A
19
TI 0137 A
TI 0148 A
H
20
H TC 0140 A
HH
TC 0140 AA
19
NOTE 4 SKIN
18 17
TI 0138 A
VENDOR
TRJR
18
H
16
17
TT
TT
0148 A
0140 A
16
3"-MPS-011029001-103CM4P-H
15
VENDOR
14
103CS1P
103CM4P
TE
5"
0138 A
20"x16"
NOTE 4 SKIN
MIN. 12
10"x8"
NOTE 6
8"x6" 11
CL300
CL300
2"
2" 14
NOTE 1
PASS 1 3"-MPS-011028002-103CS1P-H
13
15
TRJR
10"
12"x10"
V CL300
NOTE 2
14"x12"
13
16"x14"
12 11
6"x5" 5"
10 9
10 9
011-F-0002
1-1/2"
8
8
1-1/2"-HFO-011029118-103CM4P-P 7
MIN.
7
MIN.
1"
6
SIGNAL
SIGNAL
SIGNAL
SIGNAL
FROM TC-140 C
FROM FC-0034 A
FROM FC-0034 D
FROM TC-0140 D
DS011-TRJR-480073
DS011-TRJR-480067
DS011-TRJR-480068
DS011-TRJR-480074
6231
5424
5426
6233
2"x1-1/2"
5
250 mm MIN.
103CM4P 101CH2S
3
8"-HFO-011027113-103CL4P-S
3"-MPS-011028002-103CS1P-H
2 1
2"-CLD-011029301-101CH2S-P
SIGNAL
25 7696
ATM. RESIDUE
DILUTION STEAM
TO 011-C-0003
FROM 011-G-0014-A/B
FROM 011-FV-0036 A
DS011-TRJR-480067 3298
DS011-TRJR-480067 3297
DS011-TRJR-480078 3335
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- CONNECTION FOR PIPING (MECHANICAL DECOKING SYSTEM SPOOL PIGGING REPLACED BY PIGGING ELBOW DURING MAINTENANCE). 2- SPOOL PIECES SHALL BE MINIMUM DISTANCE FROM THE HEATER. 3- OP. PRESS.: 5.5 barg - 0.4 bara. OP. TEMP.: 354 TO 410ºC. DES. PRESS.: 12 barg-FV. 4- SKIN THERMOCOUPLE SUPPLY BY VENDOR. 5- COIL MATERIAL: 5cr+3mm. 6- WELDED JOINT. 011-F-0002 barg °C barg Gcal/h
5.50 354.00 12.00 41.19
NOTE 5 NOTE 3 NOTE 3 NOTE 3
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
TO TC-0140 D
FROM FC-0034 B
TO TC-140 C
DS011-TRJR-480074
DS011-TRJR-480067
DS011-TRJR-480073
6232
SIGNAL
6229
5422
6230
05
13-MAR-2013
AB
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
2
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / STG
AVS / MAC
AR
SIGNAL
SIGNAL
TO TY-0140 A
FROM FC-0034 C
DS011-TRJR-480312
DS011-TRJR-480068
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDV / MAC
JAL
5418
5420
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
IRG / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS.
3
SIGNAL
SIGNAL TO AIR / FUEL RATIO SYSTEM DS011-TRJR-480118
1
ATM. RESIDUE
HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
5 4
20"-HFO-011029101-101CM2P-H
4
6
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM HEATER PASS 1-PROCESS COIL
Project:
011-074 011-076 011-075 011-080
Item Tags :
ORIGINAL SIGNED IN PROJECT FILE
011-F-0002
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480071 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480071 2271-011-PID-0021-029
REV: 05
Sheet: 1 of 9
SCALE: NONE Format:
A1
41 40 39
41
011-F-0002 VACUUM HEATER
40
SIGNAL 6235
39
TO TY-0140AA
38 6234 37
38
SIGNAL FROM TY-0140AA
37
36
36
35
35
34
34
33
33
PI 0102 B
32
32
31
31
PI 0101 B
30
STRIPPING STEAM FROM HEADER
PT 0102
16"
12"
29
INST. PIPING
28 27
TI 1"
1"
1"
1" 8"x6"
6"x5"
30 29
H
0134 B
8"-HFO-011028109-103CL4P-S
PASS 2
STRIPPING STEAM TO 011-C-0003
SEE DWG. DS011-TRJR-480079
TE
NOTE 4 0134 B SKIN
28 27
V 5"-HFO-011029102-103CM4P-H
26
NOTE 2
TI 0136 B
25
26
H
25
24
TE 0135 B
TE 0136 B
23
NOTE 4 SKIN
ZC
TI 0135 B
24
0336 23
NOTE 4 SKIN
22
22
ZC 21
TY OP 0140 B
0334
21
20
20
19 18
TE
TI
0137 B
0137 B
TI 0148 B
H
HH
19
SP
TRJR
16
17
TI
VENDOR
18
0140 B
NOTE 4 SKIN
17
H
TC
H
VENDOR
TRJR
TT
0138 B
16
TT
0148 B
0140 B
15
TE 0138 B
3"-MPS-011029002-103CM4P-H
13
103CS1P PASS 2
12
103CM4P
2" CL300 20"x16"
NOTE 4 SKIN
3"-MPS-011028005-103CS1P-H 10"
MIN. 11
10"x8"
NOTE 6
8"x6"
10
14
2" CL300
CL300
14
15
13
NOTE 1
V
16"x14" 12"x10"
12
14"x12"
11
NOTE 2
10
6"x5" 5"
9
9
011-F-0002
8
8
7
7
1-1/2"-HFO-011029119-103CM4P-P
6
6
1"
MIN.
5
MIN.
5
2"x1-1/2"
4
20"-HFO-011029101-101CM2P-H
8"-HFO-011028109-103CL4P-S
3"-MPS-011028005-103CS1P-H
2 1
103CM4P 101CH2S
250 mm MIN.
3
2"-CLD-011029302-101CH2S-P
25 7705
ATM. RESIDUE
DILUTION STEAM
FROM 011-G-0014
FROM 011-FV-0036 B
DS011-TRJR-480067 3296
DS011-TRJR-480067 3295
2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- CONNECTION FOR PIPING (MECHANICAL DECOKING SYSTEM. SPOOL PIGGING REPLACED BY PIGGING ELBOW DURING MAINTENANCE). 2- SPOOL PIECES SHALL BE MINIMUM DISTANCE FROM THE HEATER. 3- OP. PRESS.:5.5 barg - 0.4 bara, OP.TEMP.: 354-410 ºC, DES. PRESS.: 12 barg + FV. 4- SKIN THERMOCOUPLE SUPPLY BY HEATER VENDOR. 5- COIL MATERIAL: 9 Cr + 3 mm. 6- WELDED JOINT. 011-F-0002 5.50 354.00 12.00 41.19
DS011-TRJR-480312
DS011-TRJR-480067
5547
5600
4 3 2 1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
TO 011-C-0003
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
AVS / MAC
JAL
DS011-TRJR-480078 3341
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDV / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
IRG / FCB
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001).
barg °C barg Gcal/h
SIGNAL TO FC-0034 B
ATM. RESIDUE
GENERAL NOTES
HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
SIGNAL FROM FC-0033A
NOTE 5 NOTE 3 NOTE 3 NOTE 3
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM HEATER PASS 2-PROCESS COIL
011-074 011-076 011-075 011-080
Item Tags :
011-F-0002
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480072.pid
Discipline: PRO
SA-JER-DS011-TRJR-480072 2271-011-PID-0021-029
REV:
05
Sheet: 2 of 9
SCALE: NONE Format:
A1
41
41
011-F-0002 VACUUM HEATER
40
40
39
39
38
38
37
37
36
36
35
35
34
34
PI 0102 C
33
33
32
32
31
31
PI 0101 C
30
PT 0102 C
29 28
1"
1"
1"
1"
STRIPPING STEAM FROM HEADER
16"
TI 0134 C
8"x6"
8"-HFO-011027115-103CL4P-S
STRIPPING STEAM TO 011-C-0003
SEE DWG. DS011-TRJR-480079
INST. PIPING
27
PASS 3
12"
6"x5"
H
30 29
TE
NOTE 4 0134 C SKIN
28 27
V 5"-HFO-011029103-103CM4P-H
26
26
TI
25
H SKIN NOTE 4
0136 C 2"
24 23
TE 0135 C
25 24
TI 0135 C
ZC
TE NOTE 4 0136 C SKIN
22
23
0336 22
21
21
ZC 0334
20
TY
OP
20
0140 C 19 18 17
TE
TI
0137 C SKIN NOTE 4
0137 C
H
14
VENDOR
TT 0148 C
H
16
TT 0140 C
15
VENDOR
2" CL300
2" CL300
TRJR
14
20"x16" TE 103CS1P PASS 3
103CM4P
MIN.
14"x12"
10"
10"x8" 8"x6"
NOTE 6
10
NOTE 1 12"x10"
NOTE 4
0138 C SKIN
3"-MPS-011028006-103CS1P-H
11
V CL300
13
16"x14"
12 11
NOTE 2
10
6"x5" 5"
9
20"-HFO-011029101-101CM2P-H
9
011-F-0002
8
1-1/2"
7 6
1-1/2"-HFO-011029120-103CM4P-P
MIN. 1"
MIN.
5
8"-HFO-011027115-103CL4P-S
3"-MPS-011028006-103CS1P-H
3
ATM. RESIDUE
DILUTION STEAM
FROM 011-G-0014 A/B
FROM 011-FV-0036 C
DS011-TRJR-480068 3292
DS011-TRJR-480068 3291
2"x1-1/2"
103CM4P 101CH2S 2"-CLD-011029303-101CH2S-P
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
SIGNAL
3
SIGNAL
FROM TY-0140AA
TO TY-0140AA
SIGNAL FROM FC-0033A
SIGNAL TO FC-0034 C
DS011-TRJR-480071
DS011-TRJR-480071
DS011-TRJR-480312
DS011-TRJR-480068
6231
6230
5522
5582
2 1
25 7767
1- CONNECTION FOR PIGGING (MECHANICAL DECOKING SYSTEM. SPOOL PIGGING REPLACED BY PIGGING ELBOW DURING MAINTENANCE). 2- SPOOL PIECES SHALL BE MINIMUM DISTANCE FROM THE HEATER. 3- OP. PRESS: 5.5 barg-0.4 bara OP. TEMP.: 354 TO 410ºC. DES. PRESS: 12barg+FV. 4- SKIN THERMOCOUPLE SUPPLY BY VENDOR. 5- COIL MATERIAL: 9 Cr + 3 mm. 6- WELDED JOINT.
5.50 354.00 12.00 41.19
5
DS011-TRJR-480078 3345
NOTES
barg °C barg Gcal/h
6
TO 011-C-0003
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTE 5 NOTE 3 NOTE 3 NOTE 3
7
ATM. RESIDUE
GENERAL NOTES
011-F-0002
8
4
250 mm MIN.
4
HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
18
SP
0148 C
3"-MPS-011029003-103CM4P-H
12
1
19
0138 C
13
2
H
17
TI TRJR
HH
TI
16 15
TC 0140 C
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDV / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUE FOR DESIGN
IRG / STG
RDP / MAC
JAL
REV
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
AMD CND
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
AMINE CLOSED DRAIN TURBINE CONDENSATE
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080 011-079 011-071
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PASS 3-PROCESS COIL VACUUM HEATER
Item Tags : 011-F-0002
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480073 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480073 2271-011-PID-0021-029
REV: 05
Sheet: 3 of 9
SCALE: NONE Format:
A1
41
41
011-F-0002 VACUUM HEATER
40
40
39
39
38
38
37
37
36
36
35
35
34
34
33
33
PI 0102 D
32
32
31 30
PI
PT
0101 D
0102 D
29 28
1"
1"
1"
1"
TE
NOTE 4 0134 D SKIN
0134 D
8"x6"
26
6"x5"
30 29
H
TI
8"-HFO-011027116-103CL4P-S
STRIPPING STEAM TO 011-C-0003
SEE DWG. DS011-TRJR-480079
INST. PIPING
27
PASS 4
12"
STRIPPING STEAM FROM HEADER
31
16"
28 27
V 5"-HFO-011029104-103CM4P-H
NOTE 2
H TI 0136 D
25
26
SKIN NOTE 4
25
TE 0135 D
24
TI 0135 D
24
ZC 23
TE NOTE 4 0136 D SKIN
22
23
0336
22
21
OP TY 0140 D
ZC
21
0334
20
20
NOTE 4
19
TE 18
0137 D SKIN
17
19
TI
H
0137 D
TRJR
TE NOTE 4 0138 D SKIN
13
VENDOR
103CM4P 10" MIN.
10"x8" 8"x6"
NOTE 6
10
17 16 15
TRJR
14
2" CL300
20"x16" 13
3"-MPS-011028009-103CS1P-H
11
18
TT 0140 D
2" CL300
12
PASS 4
0140 D
H
VENDOR
3"-MPS-011029004-103CM4P-H
103CS1P
0148 D
TT 0148 D
V
CL300
14
TC
H
0138 D
15
TI
SP TI
16
HH
NOTE 1 12"x10"
14"x12"
16"x14"
12 11
NOTE 2
10
6"x5" 5"
9
9
8
8
011-F-0002
1-1/2"
7 6
1-1/2"-HFO-011029121-103CM4P-P
7
1" MIN.
5
2"x1-1/2" 4
103CM4P 101CH2S
250 mm MIN.
8"-HFO-011027116-103CL4P-S
3"-MPS-011028009-103CS1P-H
3
1
5
SIGNAL
2"-CLD-011029304-101CH2S-P 20"-HFO-011029101-101CM2P-H
4
2
6
MIN.
25 7785
FROM TY-0140 AA
TO TY-0140 AA
SIGNAL FROM FC-0033 A
SIGNAL TO FC-0034 D
DS011-TRJR-480071
DS011-TRJR-480071
DS011-TRJR-480312
DS011-TRJR-480068
6232
6233
5524
5583
2 1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
ATM. RESIDUE
DILUTION STEAM
ATM. RESIDUE
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDV / MAC
JAL
FROM 011-G-0014 A/B
FROM 011-FV-0036 D
TO 011-C-0003
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JVM / SGT
RDP / MAC
JAL
DS011-TRJR-480068 3289
DS011-TRJR-480068 3287
DS011-TRJR-480078 3347
REV
PREPARED BY
CHECKED BY
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- CONNECTION FOR PIPING. (MECHANICAL DECOKING SYSTEM SPOOL PIGGING REPLACED BY PIGGING ELBOW DURING MAINTENANE). 2- SPOOL PIECES SHALL BE MINIMUM DISTANCE FROM THE HEATER. 3- OP. PRESS: 5,5 barg-0,4 barg. OP.TEMP.: 154ºC TO 410ºC. DES. PRESS.: 12 barg+FV. 4- SKIN THERMOCOUPLE SUPPLY BY VENDOR. 5- COIL MATERIAL: 9Cr+3mm. 6- WELDED JOINT.
HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
3
SIGNAL
011-F-0002 barg °C barg Gcal/h
5.50 354.00 12.00 41.19
NOTE 5 NOTE 3 NOTE 3 NOTE 3
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
Item Tags : 011-F-0002
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM HEATER PASS 4-PROCESS COIL ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480074 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480074 2271-011-PID-0021-029
REV: 05
Sheet: 4 of 9
SCALE: NONE Format:
A1
41
41
011-F-0002 VACUUM HEATER
40
40
SIGNAL FROM TC-0140F
39
6293
38
39 38
SIGNAL TO TC-0140F
37
37 6292
36
36
35
35
34
34
PI 0102 E
33
33
32
32
31
PI 0101 E
30 29
INST. PIPING
28
PASS 5
STRIPPING STEAM FROM HEADER
1"
0134 E
1" 8"x6"
26
STRIPPING STEAM
SEE DWG. DS011-TRJR-480079
1"
8"-HFO-011027117-103CL4P-S
31
16"
12"
TI 1"
27
PT 0102 E
6"x5"
30 29
H
TE
TI 0135 E
0134 E NOTE 4 SKIN
TE 0135 E
V
28
SKIN NOTE 4
TY 0140 BA
5"-HFO-011029105-103CM4P-H
27
PV 26
NOTE 2 TI 0136 E
25
H
25
SKIN
24
24
TE NOTE 4 0136 E SKIN
23 22
23
ZC 0336
22
21
21
ZC
20
20
0334
TY
OP
0140 E
19
TE 18
TI
0137 E SKIN NOTE 4
17
HH
0137 E
TC
TI
H
H
18
TC
0140 E
0148 E TI
16
19
H
0140 BA
17
SP 16
0138 E
15
TRJR
14
VENDOR TE
3"-MPS-011029005-103CM4P-H
103CM4P
NOTE 1 VENDOR
12
PASS 5
3"-MPS-011028007-103CS1P-H MIN.
11
10"x8" 8"x6"
NOTE 6
10
15 14
2" CL300
NOTE 4
0138 E SKIN
13
103CS1P
TT 0140 E
TT 0148 E
10"
12"x10"
V CL300
NOTE 2
20"x16"
2" CL300 13
TRJR 14"x12"
16"x14"
12 11 10
6"x5" 5"
9 8
9 8
011-F-0002 1-1/2"
7 6
1-1/2"-HFO-011029122-103CM4P-P
7 SIGNAL
SIGNAL
SIGNAL
FROM FC-0034G
TO TC-0140G
FROM TC-0140G
SIGNAL FROM FC-0033B
FROM FC-0034H
DS011-TRJR-480070
DS011-TRJR-480077
DS011-TRJR-480077
DS011-TRJR-480312
DS011-TRJR-480070
6308
6309
5549
6254
MIN. 1"
5
MIN.
6253
SIGNAL
6 5
2"x1-1/2"
4
4
103CM4P 101CH2S
250 mm MIN.
25 7790
ATM. RESIDUE
FROM 011-G-0014 A/B
FROM 011-FV-0036 E
TO 011-C-0003
DS011-TRJR-480069 3303
DS011-TRJR-480069 3302
DS011-TRJR-480078 3304
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- CONNECTION FOR PIGGING (MECHANICAL DECOKING SYSTEM SPOOL PIGGING REPLACED BY PIGGING ELBOW DURING MAINTENANCE). 2- SPOOL PIECES SHALL BE MINIMUM DISTANCE FROM THE HEATER. 3- OP. PRESS.: 5.5 barg - 0.4 bara. OP. TEMP.: 354 ºC TO 410 ºC. DES. PRESS.: 12 barg + FV. 4- SKIN THERMOCOUPLE SUPPLY BY VENDOR. 5- COIL MATERIAL 9 Cr + 3 mm 6- WELDED JOINT.
9 Cr + 3 mm 5.50 354.00 12.00 41.19
NOTE 5 NOTE 3 NOTE 3 NOTE 3
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
SIGNAL
FROM TC-0140H
FROM FC-0034E
SIGNAL TO FC-0034-E
DS011-TRJR-480119
DS011-TRJR-480078
DS011-TRJR-480078
DS011-TRJR-480069
DS011-TRJR-480069
6313
6314
5425
4183
05
13-MAR-2013
AB
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
2
04
30-SEP-2011
03 SIGNAL FROM FC-0034 F
DS011-TRJR-480069 5423
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDV / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
IRG / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS.
3
1
DILUTION STEAM
barg °C barg Gcal/h
SIGNAL
TO TC-0140H
6310
ATM. RESIDUE
011-F-0002
SIGNAL
AIR/FUEL RATIO SYSTEM
2"-CLD-011029305-101CH2S-P
GENERAL NOTES
HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
SIGNAL
20"-HFO-011029101-101CM2P-H
1
8"-HFO-011027117-103CL4P-S
2
3"-MPS-011028007-103CS1P-H
3
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM HEATER PASS 5-PROCESS COIL
Project:
011-074 011-076 011-075 011-080
Item Tags :
011-F-0002
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480075 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480075 2271-011-PID-0021-029
REV: 05
Sheet: 5 of 9
SCALE: NONE Format:
A1
41
41
011-F-0002 VACUUM HEATER
40 39
6293
40
SIGNAL
39
TO TY-0140 BA
38 37
38 SIGNAL 6292
37
FROM TY-0140 BA
36
36
35
35
34
34
33
33
32
32
PI 0102 F
31
31
30
30
29
PI 0101 F
PT 0102 F
16"
12"
STRIPPING STEAM FROM HEADER
29
STRIPPING STEAM TO 011-C-0003
SEE DWG. DS011-TRJR-480079
28
28
26 25
PASS 6
1"
1"
1"
1"
TI 0134 F
8"x6"
8"-HFO-011027118-103CL4P-S
6"x5" RS NOTE 2
24
H
27
TE 0134 F NOTE 4 SKIN
26
V 25
TI
5"-HFO-011029106-103CM4P-H
INST. PIPING
27
H
0136 F
23 22
TE NOTE 4 0136 F SKIN
21 20
24
SKIN NOTE 4 TE
TI
ZC
0135 F
0135 F
0336
23 22 21
ZC 0334
20
19
19
18
18
SP NOTE 4
17
TE 0137 F SKIN
16 15
TI 0138 F
14
TRJR
13
11
103CS1P PASS 6
10
TC
H
TY
0140 F
OP
17
0140 F 16 15
H TT 0148 F
SKIN
TT 0140 F
14 13
VENDOR
TE
NOTE 4 0138 F SKIN
103CM4P
10"x8" 8"x6"
NOTE 6
2" CL300 12
NOTE 1 10"
MIN.
2" CL300
TRJR 20"x16"
3"-MPS-011028010-103CS1P-H
9
HH
VENDOR
3"-MPS-011029006-103CM4P-H
12
TI 0148 F
H
TI 0137 F
12"x10"
11
14"x12"
16"x14" 10
V CL300 NOTE 2
9
6"x5"
8
8
5"
7
7
011-F-0002
6
6
1-1/2"
5
5
1-1/2"-HFO-011029123-103CM4P-P
4
MIN.
2"x1-1/2" 20"-HFO-011029101-101CM2P-H
2"-CLD-011029306-101CH2S-P
25 7792
FROM FC-0033 B
SIGNAL TO FC-0034 F
DS011-TRJR-480312
DS011-TRJR-480069
5548
4187
2 1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / STG
AVS / MAC
JAL
ATM. RESIDUE
DILUTION STEAM
ATM. RESIDUE
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDV / MAC
JAL
FROM 011-G-0014 A/B
FROM 011-FV-0036-F
TO 011-C-0003
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JVM / SGT
RDP / MAC
JAL
DS011-TRJR-480069 3300
DS011-TRJR-480069 3299
DS011-TRJR-480078 3305
REV
DATE
COMPANY STATUS
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- CONNECTION FOR PIPING (MECHANICAL DECOKING SYSTEM SPOOL PIGGING REPLACED BY PIGGING ELBOW DURING MAINTENANCE). 2- SPOOL PIECES SHALL BE MINIMUM DISTANCE FROM THE HEATER. 3- OP. PRESS.: 5.5 barg - 0.4 bara. OP. TEMP.: 354 TO 410ºC. DES. PRESS.: 12 barg-FV. 4- SKIN THERMOCOUPLE SUPPLY BY VENDOR. 5- COIL MATERIAL: 5cr+3mm. 6- WELDED JOINT. HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
3
SIGNAL
103CM4P 101CH2S
250 mm MIN.
3"-MPS-011028010-103CS1P-H
8"-HFO-011027118-103CL4P-S
1
4
1"
3 2
MIN.
011-F-0002 barg °C barg Gcal/h
5.50 354.00 12.00 41.19
NOTE 5 NOTE 3 NOTE 3 NOTE 3
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
Item Tags : 011-F-0002
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM HEATER PASS 6-PROCESS COIL ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480076.pid
Discipline: PRO
SA-JER-DS011-TRJR-480076 2271-011-PID-0021-029
REV:
05
Sheet: 6 of 9
SCALE: NONE Format:
A1
41
41
011-F-0002 VACUUM HEATER
40
40
39
39
38
38
37
37
36
36
35
35
34
34
33
33
PI 0102 G
32
32
31
31
30
PI
PT
0101 G
0102 G
29
1" 28
1"
1"
TE
NOTE 4 0134 G SKIN
0134 G
1" 8"x6"
30 29
H
TI
8"-HFO-011027119-103CL4P-S
STRIPPING STEAM TO 011-C-0003
SEE DWG. DS011-TRJR-480079
INST. PIPING
27
PASS 7
16"
STRIPPING STEAM FROM HEADER
28 27
V
6"x5"
5"-HFO-011029107-103CM4P-H
26
NOTE 2
TI 0136 G
25
25
TE 0135 G
24 23
26
SKIN NOTE 4
H
TI 0135 G
ZC 0336 OP TY 0140 G
TE NOTE 4 0136 G SKIN
22
24 23 22
ZC 0334
21
21
H
TC
20
20
0140 G NOTE 4
19
TE 18
0137 G SKIN
SP TI
H
19
HH
TI 0148 G
0137 G
18
17
17
TI
16
H TT 0148 G
0138 G
15
TRJR
14
15
CL300
MIN.
11
VENDOR
8"x6"
10
20"x16"
TRJR
13
NOTE 1
10"x8"
NOTE 6
10"
12"x10"
V
NOTE 2
14"x12"
16"x14"
12
6"x5" 5"
9 8
1-1/2"
011-F-0002
7
1-1/2"-HFO-011029124-103CM4P-P
6
14
20"-HFO-011029101-101CM2P-H
3"-MPS-011028008-103CS1P-H
NOTE 4 0138 G SKIN
103CS1P 103CM4P
PASS 7
CL300 2"
2"
TE
12
0140 G
VENDOR
3"-MPS-011029007-103CM4P-H
13
16
TT
11 10 9 8 7
ATM. RESIDUE 6 TO 011-G-00034037
MIN. 1"
5
MIN.
5
2"x1-1/2"
4
4
8"-HFO-011027119-103CL4P-S
1
3"-MPS-011028008-103CS1P-H
2
ATM RESIDUE
DILUTION STEAM
FROM 011-G-0014 A/B
FROM 011-FV-0036 G
DS011-TRJR-480070 3321
DS011-TRJR-480070 3319
103CM4P 101CH2S
250 mm MIN.
3
SIGNAL
2"-CLD-011029307-101CH2S-P
1- CONNECTION FOR PIPING. (MECHANICAL DECOKING SYSTEM SPOOL PIGGING REPLACED BY PIGGING ELBOW DURING MAINTENANE). 2- SPOOL PIECES SHALL BE MINIMUM DISTANCE FROM THE HEATER. 3- OP. PRESS.: 5.5 barg - 0.4 bara. OP. TEMP.: 354 ºC TO 410 ºC. DES. PRESS.: 12 barg - FV. 4- SKIN THERMOCOUPLE SUPPLY BY VENDOR. 5- COIL MATERIAL: 9 Cr + 3 mm. 6- WELDED JOINT.
5.50 354.00 12.00 41.19
NOTE 5 NOTE 3 NOTE 3 NOTE 3
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
FROM TC-0140BA
DS011-TRJR-480075
DS011-TRJR-480075
DS011-TRJR-480312
DS011-TRJR-480070
6308
6309
4189
5591
2
25
NOTES
barg °C barg Gcal/h
SIGNAL TO FC-0034 G
7766
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
011-F-0002
TO TY-0140BA
SIGNAL FROM FY-0033 B
1
GENERAL NOTES
HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
3
SIGNAL
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDV / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
IRG / STG
RDP / MAC
JAL
REV
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM HEATER PASS 7-PROCESS COIL
Item Tags : 011-F-0002
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480077 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480077 2271-011-PID-0021-029
REV: 05
Sheet: 7 of 9
SCALE: NONE Format:
A1
011-F-0002 VACUUM HEATER
41
41
40
40
39
39
38
38
37
37
36
36
35
35
34
34
33
33
32
32
31
31
PI 0102 H
30
30
NOTE 4
29
12"
28 27
PI
PT
0101 H
0102 H
16"
STRIPPING STEAM FROM HEADER
25
1"
1"
1"
1"
STRIPPING STEAM TO 011-C-0003
SEE DWG. DS011-TRJR-480079
28 27
TI
26
29
INST. PIPING
24
H
TE
0134 H
8"x6"
6"x5"
TI
TE
0135 H
0135 H
26
SKIN
NOTES 1,2
PASS 8
NOTE 7
0134 H
SKIN NOTE 7
25
V
24
ZC 0336
23
23
22
22
TI
21
H
TE
0136 H
0136 H
OP
TY
NOTE 7 SKIN
20 19
SP
18
H TC 0140 H
HH
0137 H SKIN
16 15
0148 H 17
H
TI 0137 H
TI 0138 H
16
TT 0140 H
H
TT 0148 H
15 14
TRJR
VENDOR TE
12
3"-MPS-011029008-103CM4P-H
0138 H
VENDOR
NOTE 7
2" CL300
TRJR 20"x16"
2" CL300
PIPING
13
0.2%
INSTR.
14
18
TI
NOTE 7 TE
20 19
5"-HFO-011029108-103CM4P-H
17
21
ZC 0334
0140 H
INSTR. PIPING
12
SKIN
11
10"
10
12"x10" PASS 8
9 8
11
NOTE 1
103CM4P
MIN.
10"x8" 8"x6"
NOTE 8
14"x12"
16"x14"
10
64"-HFO-011029101-101CM2P-H
103CS1P
V CL300 NOTE 2
6"x5" 5"
7
011-F-0002 6
1-1/2"
DILUTION STEAM FROM 011-FV-0036 H
103CM4P 101CH2S
DS011-TRJR-480070 3400
SIGNAL TO TY-0140 BA
SIGNAL TO FC-0034 H
DS011-TRJR-480075
DS011-TRJR-480070
6314
5590
2"-CLD-011029308-101CH2S-P
20"-HFO-011029101-101CM2P-H
2"x1-1/2"
20"-HFO-011029101-101CM2P-H
MIN.
1"
20"-HFO-011029101-101CM2P-H
MIN.
20"-HFO-011029101-101CM2P-H
1
1-1/2"-HFO-011029125-103CM4P-P
250 mm MIN.
2
8"-HFO-011027120-103CL4P-S
3
3"-MPS-011028011-103CS1P-H
4
20"-HFO-011029101-101CM2P-H
20"-HFO-011029101-101CM2P-H
ATM. RESIDUE 4037FROM PASS 7
20"-HFO-011029101-101CM2P-H
5
13
ATM. RESIDUE
ATM. RESIDUE
FROM PASS 1
FROM PASS 3
FROM PASS 5
DS011-TRJR-480071 3335
DS011-TRJR-480073 3345
DS011-TRJR-480075 3304
SIGNAL FROM TY0140 BA
SIGNAL FROM FC-0033B
ATM RESIDUE
DS011-TRJR-480075
DS011-TRJR-480312
FROM OIL G-0014 A/B
6313
4190
2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
FROM PASS 2
FROM PASS 4
FROM PASS 6
DS011-TRJR-480072 3341
DS011-TRJR-480074 3347
DS011-TRJR-480076 3305
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC/ SGT
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF/ SGT
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / SGT
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JVM / SGT
RDP / MAC
JAL
NOTES 3 DELETED. 1- CONNECTION FOR PIPING. (MECHANICAL DECOKING SYSTEM. SPOOL PIG GAS REPLACED BY PIGGING ELBOW DURING MANTENANCE). 2- SPOOL PIECES SHALL BE MINIMUM DISTANCE FROM THE HEATER. 4- FOR 64º LINE USE 90º ELBOWS R = 5D. 5- OP. PRESS: 5,5 barg-0,4 barg. OP.TEMP.: 354ºC TO 410ºC. DES. PRESS.: 12 barg-FV. 6- COIL MATERIAL: 9Cr+3mm. 7- SKIN THERMOCOUPLE SUPPLY BY VENDOR. 8- WELDED JOINT. HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
011-F-0002 barg °C barg Gcal/h
5.50 354.00 12.00 41.19
NOTE 6 NOTE 5 NOTE 5 NOTE 5
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
2
ATM. RESIDUE
ATM. RESIDUE
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
3
1
ATM. RESIDUE
DESCRIPTION
5
TO 011-C-0003
ATM. RESIDUE
POS.
6
DS011-TRJR-480081 3404
REV
GENERAL NOTES
7
4
DS011-TRJR-480070 3318
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001).
8
ATM. RESIDUE
25 6322
9
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM Project:
011-074 011-076 011-075 011-080
Item Tags : 011-F-0002
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM HEATER PASS 8- PROCEES COIL ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480078 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480078 2271-011-PID-0021-029
REV: 05
Sheet: 8 of 9
SCALE: NONE Format:
A1
41
41
011-F-0002 VACUUM HEATER
40
011-DS-0002 011-F-0002 LP STEAM DESUPERHEATER
40
INSULATION: H
39
39 38
38
37
37
36
36
35
35
34
34
33
33
TI 0447
32
H
32
31
31
30
30
TT 0447
29 28
2" CL300
27
12"
29
INSTR. PIPING
28 27
16"
26
26
25
25
24
24
4"L6" 7.00
NOTE 1 ATM
+
23
SEE DWGS. DS011-TRJR-480071 TO 480079
PZV 0017
ATM. RESIDUE TO 011-C-0003
21 20 19 18
6"x4"
PZV 0018
23 22
+
8"x6" 8"-LPS-011029002-101CJ1P-P
8"x6" 8"-LPS-011029003-101CJ1P-P NOTE 2 CL300
NOTE 2
CL300
21
6"x4"
3/4"
3/4"
V
V LO FB NOTE 4 3/4"
V
20 19
011-SP-0028
NOTE 10
17 16
NOTE 1 ATM
+
+
16"-LPS-011029007-103CJ1P-H
ATM. RESIDUE FROM 011-G-0014
22
4"L6" 7.00
LC FB NOTE 4
18
2"
3/4"
2"
17
2"
V
16
2"
6"-LPS-011029005-103CJ1P-H
15
15
103CJ1P
103CJ1P
101CJ1P
101CJ1P 14
TRJR
13
VENDOR
14
13
6"-LPS-011029006-103CJ1P-H
12
12
TC 0049
11 10
H 11
L 10
NOTE 7
9
1-1/2" CL300
TV 0049
MIN.
8
011-DS-0002
1"-BFW-011029301-101CS1P-H
103CJ1P 101CS1P
1"-BFW-011029301-101CS1P-H
NOTE 9
7
9
+
1"-BFW-011029302-103CJ1P-H
1-1/2"x1"
6
FLC CL300 3/4" D
3/4" D
8 15
7
6185
6
CL300 1"
5
NOTE 8
MIN.
011-F-0002
4
5
NC
3
4
RO 0071 +
PIPING INSTR.
3
TT
1
16"-LPS-011029004-101CJ1P-H
12"-LPS-011040001-101CS1P-H
2
LP STEAM
STRIPPING STEAM
FROM 011-D-0011
TO 011-C-0003
DS011-TRJR-480105 3306
DS011-TRJR-480106 3307
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES
HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
011-F-0002 barg °C barg Gcal/h
5.50 354.00 12.00 41.19
NOTE 6 NOTE 5 NOTE 3 NOTE 3 NOTE 3
DESUPERHEATERS TYPE INLET STEAM kg/h OP. PRESS. barg OP. TEMP. °C in/out DES. PRESS. barg DES. TEMP. °C
011-DS-0002 VAD 17600.0 2.20 396.00 350.00 7.00 435.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
2" CL300
1- TO ATMOSPHERE AT SAFE LOCATION. 2- 10mm WEEP HOLE AT LOW POINT. 3- OP. PRESS.: 5.5 barg.-0.4 bara., OP. TEMP: 354 - 410 º C. DES. PRESS: 12 barg + FV. 4- GATE VALVE SHALL BE INSTALLED WITH STEM IN OR BELLOW THE HORIZONTAL POSITION. 5- COIL MATERIAL: 9 Cr + 3 mm. 6- STEAM COIL CONDITIONS: OP. PRESS: 2.5 barg - 2.25 barg. OP. TEMP: 148 ºC - 382 ºC. DES.PRESS: 7.0 barg + FV. 7- CONTROL VALVE SUPPLIES DESUPERHEATER VENDOR. 8- MINIMUM DISTANCE REQUIRED TO TEMP. SENSOR (TT-0049) 10m. 9- REQUIRED 2m OF STRAIGHT LENGTH PIPE UPSTREAM 011-DS-0002 AND 5m DOWNSTREAM. 10- MECHANICAL LINK.
2
0049
1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MRM / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
IRG / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM HEATER ORIGINAL SIGNED IN PROJECT FILE
Item Tags : 011-F-0002
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480079.pid
Discipline: PRO
SA-JER-DS011-TRJR-480079 2271-011-PID-0021-029
REV:
05
Sheet: 9 of 9
SCALE: NONE Format:
A1
011-C-0003 VACUUM COLUMN
41 40
2102
41
HH
PI 0067
PT 0067
40
INST. PIPING
SEE DETAIL "B" 39
1" NOTE 10
60"-PRO-011030001-101CH4S-P
NOTE 7 37
35 34
CL300 14"x8" 1"
TI 0143
1"
NOTE 4 FB LO
14" NOTE 5
FB LO
14" NOTE 5
FB LC
14" NOTE 5
INST. PIPING
24"x14"
28
LC 0044
HPT 29
27
3/4"-LFL-011030304-101CH2F-N
H
101CH2F 101CS1P
V4
ID
24"
0143
M10 W1
A7
MIN.
NC 24
3/4" D
MIN. 23
MAG
INST. PIPING NOTE 3 2" 2"
MAG
1/4" D
BED 4
PIPING
LG 0043
22
LT 0044
21
PIPING. INST. MIN.
1/4" D
ZYV 0083
M9
1/4" D LT 0054 2" 2"
L11A
NC 3/4"
17
2"x3/4"
14" 2" 2"
2"
TT 0144
T5
PIPING
2106
MIN. 3/4"-HFO-011030010-101CL2P-P
NC
11
2" 2"
3/4" D
10
2" 2"
MAG
MIN. 9
PIPING INST. MIN.
8 7
NOTE 3
NC
6
0145
BED 3
L8B
2"
ID
MIN.
3
1
L
M7
LT 0053
SIGNAL TO FC-0144
2" 2"
L9A
9
B3
NOTE 3
1/4" D
8"-HFO-011030002-101CL2P-S
P7 2"
2" T4
2"
ZYV 0086
1/4" BY PIPING BY INST.
ZLO
ZYC
ZHA
0086
0086
0086
0086
CL
2mm
DETAIL "B" 011-C-0003 50150.0 9000.0 -0.90 80.00 3.50 430.00 + FV
12 11
ATM ZLS 0086 C
PI
0069
0069
ZLS 0086 O
ZY 0086
ZHS 0086
FC TSO
2" CL300
M6
REMOVABLE ELBOW 3" FLOW
NOTE 12
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
CL
1"
101CH4S 101SC1P
10 9 8
2"x1"
TT 0200
TI
7 6 5 4 3
0200
4034
HVGO PA
MVGO
LVGO REFLUX
LVGO
NEUTRALIZING AGENT
FROM 011-S-0001
TO 011-G-0016
FROM 011-G-0015
TO 011-G-0015
FROM 011-X-0004
DS011-TRJR-480141 3311
DS011-TRJR-480099 3312
DS011-TRJR-480096 3313
DS011-TRJR-480096 3314
DS011-TRJR-480126 3315
NOTES
mm mm barg °C barg °C
13
ZLC
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
O
16
OPEN POSITIONER BY-PASS
CLOSED
GENERAL NOTES
1" 33.4mm EXT.
17
14
ID 24"
DS011-TRJR-480099
1/4" BY INST.
18
5031
1" OR 1/2"
60
19
2"-CLD-011030305-101CH2S-N
PIPING INST.
DIAPHRAGM SEAL + AS PER PIPING CLASS SPEC. ADAPTER
16- MATERIAL SPECIFICATION BREAK CHANGE IN FLO CONNECTIONS PENDING ON COMPANY´S INSTRUCTION TO PROCEED.
COLUMN TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
103CS1P 101CH2S
+
S
+
PT
2"
2"-CLD-011030302-101CH2S-P
DS011-TRJR-480098
BY PIPING
20
2" CL300
14" TI 0145
21
0356
ZV 0086
8"
2"
SIGNAL TO FC-0155A
4030
D 2"x3/4"
ZC
LI 0053
2"
BED 2
1" OR 1/2"
3m MIN.
TT 0199
ZHS 0083
22
ZHSR 0086
LL
DETAIL "D" 011-C-0003
DIAPHRAGM SEAL + AS PER PIPING CLASS SPEC. ADAPTER
ZC 0316
DE
25
DETAIL "C" 011-C-0003
ZY 0083
D 3/4"
15
IA
2919
DETAIL "A"
ZLS 0083 O
3/4"-DIE-011030003-103CS1P-P
101CL2P 101CH2S
250mm MIN.
2
H
23
RESET
2"
A5
LC 0046
2"x3/4"
2" 2"
24
1/4" D
3/4"-HFO-011030004-101CL2P-S
4
L7B
ID 24"
3/4"
5
0083
25
ES
L7A
INST. PIPING TT
MIN.
L9B
INST. PIPING 2" 2" 2" L8A 1/4" D 2"
0083
FC TSO NOTE 8
ES ZHXS NOTE 9 PUMP STOP 0086 L NOTE 9 ZC INST. 0356
PIPING
2"
1/4" D
LT 0046
LG 0045
2"
0083
26
25
ZHXS 0086
INST. PIPING
2920
MIN.
12
PIPING INST.
0083
14"-HFO-011013006-101SD0P-S
101CH2F 101CL2P
25
ZHA
28
NC
0199
6"-DIE-011037004-101CS1P-H
2"-CLD-011030301-101CH2S-P
13
ZYC
1/2"
29
INST. PIPING
10"x6"
6"
INST.
A6
ID 24"
M8
NOTE 7
ZLO
31
CL300
27
0068
6"
101CS1P 101CH2S
250mm MIN.
29
14
BY-PASS
ZLC
ZLS 0083 C
ZV 0083
PI
PT 0068
P8
16
HPT
TI OPEN POSITIONER
2"
8" 10"x8"
MIN.
ATM
NOTE 1 18"-DIE-011030001-101CS1P-H NOTE 1
18"x14"
MIN. TI 0144
10"x6"
+
B4A
10"x8"
DE
NOTE 3
B4B
INST. PIPING
3/4"-DIE-011030005-101CS1P-S
DE
IA
14" 1/4" D 18"x14"
10
MIN.
18
LI 0054
0083 L NOTE 9 CLOSED
S
L10A
L12A
19
ZC 0355
ES
LL
2"
20
0083
2" 2"
ID 24"
1/2"
+
FO
ZHXS
L10B
L11B
INST. PIPING 2" 2"
3/4"-LFL-011030305-101CH2F-N
ZC 0312
+
MIN.
15
ZC 0355
INST.
FV 0038
ZHXS ES
ZHSR 0083
33
CL300
30
FT 0038
1"-CHP-011054003-101SC1P-N
RESET
2"
TT 0205
L
0038
10"-DIE-011030002-101CS1P-P
PUMP STOP L12B
H
3/4" D
10"
NOTES 13,14,15 2" 2"
0198
32
T7
011-C-0003
0198
TI 0205
4"-FLO-011037301-101CS1P-N NOTE 16
FLO
2"
ID 24"
TT
FC
6312
P12
0066
PIPING INST. MIN. 3/4"-DIE-011030006-101CS1P-P
25
D
NOTE 2
NOTE 7
D
TT
60"x56" 56" B5B
V
6"
2" 2"
PI
L
60"x56" 56" B5A
2105
26
3/4"
MIN.
24"-PRO-011030003-101CH4S-P
29
3/4"
TC
NO POCKET NO POCKET
NOTE 5
60"-PRO-011030001-101CH4S-P
2"
30
FB LO
36
+
14"x10"
1"
011-SP-0029
NOTE 10
PZV 0020
1" 1"
NOTE 4 14" NOTE 5
14"x8"
1" 1"
31
101CH2F 101CH4S
CL300
NOTE 5
37
NO POCKET NO POCKET
14"x8"
1"
32
101CH2F 101CH4S
CL300
SEE DETAIL "B"
60"-PRO-011030002-101CH4S-P
NOTE 5
LO FB
INST. PIPING
10"-DIE-011037008-103CS1P-P
14"x6"
1" V
33
101CH2F 101CH4S
CL300
NOTE 5
3/4" V
PZV 0019 A
14"x10"
60"-PRO-011030002-101CH4S-P
+
+
LO FB
+
0305
MIN.
14"x8"
3/4" V
PZV 0019 B
L
250mm MIN.
34
LO FB
+
0305
101CS1P 103CS1P
NC
3/4" V LO 14"x10" FB
PZV 0019 C
8"T10" 3.50
+
+
PT 1"
8"-HFO-011030002-101CL2P-S
101CH2F 101CH4S
35
8"T10" 3.50
8"T10" 3.67
+
H
6"-DIE-011037004-101CS1P-H
6"R8" 3.67
2" 36
38
PI
MIN.
29
ZC 0321
2"-CHP-011054003-101SC1P-N
38
0.2%
ZC 0334
18"-DIE-011030001-101CS1P-H
26"-LFL-011030301-101CH2F-N
TRIM: PRO-011030601-101CH4S / PRO-011030602-103CH4S / DIE-011030601-103CS1P / HFO-011030601-103CL2P INSULATION: H
101CH2F 101CH4S
39
ZC 0372
6,11 DELETED. 1- PROVIDE MINIMUM VERTICAL RUN OF THE HIGHEST OF 3 METERS FROM NOZZLE, AT NOZZLE SIZE, BEFORE REDUCING SIZE OF THE LINE: SEE DETAIL "A". 2- VERTICAL HEIGHT MIN. 3000 mm. 3- ENSURE THAT NOZZLES FOR LEVEL TRANSMITTERS ARE AT THE SAME ELEVATION. 4- MECHANICAL LINK. 5- BLOCK VALVE SHALL BE INSTALLED WITH THE STEM IN OR BELOW THE HORIZONTAL POSITION. 7- CONNECTION ON TOP OF THE FLARE SUBHEADER. 8- INSTALL ZV VALVE MINIMUM DISTANCE FROM 011-C-0003 NOZZLE. 9- LOCAL EMERGENCY HAND SWITCH BEHIND FIREWALL OR AT SAFE LOCATION. 10- INJECTION CONNECTION AFTER THE HIGH POINT OF THE LINE. 12- OP. TEMP (ºC) TOP/BOTTOM : 80 / 360. OP. PRESS (barg.) TOP/BOTTOM: -0.89/-0.83. 13- FOR NOZZLES DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING. 14- FOR INSTRUMENTS NOZZLES (EXCEPT TEMPERATURE INSTRUMENTS) ABOVE "BED 3" SEE DETAIL "C". 15- FOR INSTRUMENTS NOZZLES (EXCEPT TEMPERATURE INSTRUMENTS) BELOW "BED 3" SEE DETAIL "D".
05
13-MAR-2013
AB
04
30-SEP-2011
03
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
FLUSHING OIL
VDU OVERHEAD
TO 011-E-0025
TO 011-E-0025
DS011-TRJR-480097 3316
DS011-TRJR-480082 3317
DS011-TRJR-480083 8966
2 1
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
RDP / MAC
JAL
00
11-DEC-09
IFD
IFD: ISSUED FOR DESIGN
MMG / JLM
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
JUBAIL EXPORT REFINERY
011-075
PIPING AND INSTRUMENT DIAGRAM Project:
011-078 011-074 011-076 011-075 011-080
FLO
VDU OVERHEAD
AB: AS BUILT
UTILITIES IDENTIFICATION POS.
LVGO PA FROM 011-A-0005
011-077
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM COLUMN
Item Tags :
011-C-0003 Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480080 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480080 2271-011-PID-0021-030
REV: 05
Sheet: 1 of 2
SCALE: NONE Format:
A1
1" OR 1/2"
3/4"-HFO-011030009-101SD0P-S
ZC
ZHSR
0311
0081
39
0081
011-C-0003
ZYV 0081
S
+
2" 2"
NOTE 4 LC 0048
34
H
D 1/4"
LT
L
101CS1P 101SD0P
31
MIN.
2" 2" L6A
MIN.
30
INST.
NC TI 0146
2"x3/4"
PIPING 2"
27
OLW
ID 24"
2"-CLD-011030303-101CH2S-P TI 0142
25
TI 0327
TT 0142
2" CL300
24
2"
TT 0327
PI
PT
0070
0070
24" B2B
28"x24"
24" B2A
28"x24"
BED 1
2"
PT 0071
NC
NC MIN.
18
1"
1"-HFO-011030110-101CL4P-S
1"-HFO-011030107-101CL4P-S
16
24"
A2A
NOTE 10 24"
32"x24"
1"x3/4"
PIPING INST.
1"x3/4"
NUCL
13
L1B
2" L3D
LG 0049 A
MAG
LT
LG 0049 B
0306
L2A
MIN. H
LC 0050
7
D
L
LI 0050 L
1"
INST. PIPING NC
L1A
M1
4
1"-HFO-011030103-101CL4P-S
3
MIN. FLO
1"-OLW-011030302-101CS1P-N
18" D1
HS 0010
101CL4P 103CL4P TSO FC
MIN.
250mm MIN.
MIN.
7803
101CS1P 101CL4P
32"-LPS-011041006-101CS1P-H
64"-HFO-011029101-101CM2P-H
1
6"-HFO-011014104-101CL2P-S
4"-FLO-011030302-101CS1P-N 2
101CL4P 101CH2S 4"-CLD-011030304-101CH2S-P
OLW SIGNAL TO FC 0049
DS011-TRJR-480024 4026
ATM RESIDUE
STRIPPING STEAM
FROM 011-F-0002
FROM 011-F-0002
VAC RESIDUE (QUENCH) FROM 011-E-0018
DS011-TRJR-480078 3404
DS011-TRJR-480106 3363
DS011-TRJR-480027 3205
SIGNAL TO LV-0050
DS011-TRJR-480103 7806
SIGNAL TO HS-0053 A
6"
NOTE 8 NOTE 8
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
0073
22
19 18
TI 0326
LI 0051 L
LT 0126
LI
NULL
H
LI 0126
17
1/2" 15
ZC
ZC
0372
0334
FT 0182
0051
LT
2" 2" MIN.
101CL4P 101CS1P
ZV 0016 +
OLW
0352
LT
LI
PUMP STOP
0127
0127 10 2152
ZHSR
0306
0016
RESET
2"x1"
PUMP VENT FROM 011-G-0017/0018
2"-CLD-011030307-101CH2S-P SIGNAL
25
TO 011-PV-0072
5035
S
+
DE
ZC 0352
7 6 5 4 3
OLW
DS011-TRJR-480084
IA
9 8
DS011-TRJR-480103 3371
ZYV 0016
10
3/4"-OLW-011030305-101CS1P-N
1"-HFO-011030108-101CM2P-S
101CM2P 101CH2S ZC
11
TI 0328
6182
WASH OIL
HVGO
FROM 011-S-0002
TO 011-G-0017
DS011-TRJR-480102 3372
DS011-TRJR-480101 3373
2 1
ATM CLOSED ZLC 0016
BY-PASS
OPEN ZLO 0016
ZYC 0016
ZHA 0016
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS / MAC
JAL
ZLS
ZLS
ZY
ZHS
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MSS / STG
AVS / MAC
JAL
0016 C
0016 O
0016
0016
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MMG / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
DS011-TRJR-480103 3366
4061
12
FI 0182
TO 011-G-0018-A/B
DS011-TRJR-480104
PIPING
INST.
LL
NOTE 12
UC 6"-HFO-011030102-101CL4P-S ES ES ZHXS ZHXS NOTE 3 0016 L 0016 A
14
TT 0328
13
0051
4"-MPS-011030301-103CS1P-H
CL300 2"
HH
ZC
11 DELETED. 1- PROVIDE MINIMUM VERTICAL RUN OF THE HIGHEST OF 3 METERS FROM NOZZLE, AT NOZZLE SIZE,BEFORE REDUCING SIZE OF THE LINE. SEE DETAIL "A". 2- INSTALL ESDV MINIMUM DISTANCE FROM C-0003 NOZZLE.
50150.0 9000.0 -0.90 80.00 3.50 /FV 430.00
0072
CLOSE STEAM INJECTION
NOTES
mm mm barg °C barg °C
PI
1/2"
1/4" D
CL150 CL300
VACUUM RESIDUE
25
8"-HFO-011030109-101CM2P-S
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
011-C-0003
27
20
GENERAL NOTES
COLUMN TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
5034
21
2"
25 2913
PT
D
LPT
4"-HFO-011030103-101CL4P-S
L
V 3/4"
18"-HFO-011030101-103CL4P-S
101CL2P 101CS1P
D
28
FLO
24
INST.
S1 4"
18"-HFO-011030111-101CL4P-S
5
30
23
PI
4"-HFO-011014104-101CL2P-S
6
31
PC 0072
PT 0306
1/4" D
2" 2"
11500 mm
3/4"
TI 0147
B1
NC
1"x3/4"
MIN.
8
33
16
2" 2"
ID 24"
2" L3C L3A
INST. PIPING
2"
2" 2"
1/4"
2"
A3
2"
INST. PIPING 1"
TT 0147
L2B
PIPING 2" 6"
10 9
H
2"
0050
2"
11
MIN. 1"x3/4"
CL300
26
0074
2"
LE
INST.
MAG
ZHS 0081
8"-HFO-011030109-101CM2P-S
2"
P1
L3B 12
3/4"
PT 0103 B
PIPING
0050
ZY 0081
2"-HFO-011039105-101CL4P-S
PIPING 2"
MIN.
14
INST.
PIPING INST.
2"-FLO-011030301-101CS1P-N
H
2" V1
24" A2B
3/4" D 15
ID 24" 6
24" 32"x24"
32"-LPS-011041006-101CS1P-H
ZLS 0081 O
29
2"-HFO-011030109-101CM2P-S PDI 0103
PIPNG INST. 2" 2" P2 2" P3 INST. PIPING 2" 2" 2" P4 8" A8 PIPING INST. 2" TT T1 0326
1
NOTE 10
1"
34
FC TSO NOTE 2
PI 0071
PT 0103 A
6"-OLW-011030301-101CS1P-N
17
M2
MIN.
101CH2F 101CL4P
19
101CH2F 101CL4P
35
TT 0201
6"-HFO-011039008-101SD0P-S
T2
64" A1
NOTE 6
ZLS 0081 C
NOTE 1
PI
2108
20
ZHA 0081
32
B7 8"
1"-LFL-011030303-101CH2F-N
29
ZYC 0081
MIN.
7
HPT 21
ZLO 0081
28"-HFO-011030001-101CL2P-S
ID 24" PIPING M3
HPT
NOTE 5
ZLC 0081
36
0357
LL
+
P10A
T6
INST.
ATM
ZV 0081
2" 2"
MIN. 64"-HFO-011029101-101CM2P-H
0.2%
ZC
OPEN POSITIONER BY-PASS
PUMP STOP
2"
22
0052
P10B 2" 2"
M4
2" 2" P5
2918
23
0052
PIPING INST.
26 25
LI
6" A4
101SD0P 101CH2S
250mm MIN.
28
2" 2"
P6 2"
T3
3/4"-OLW-011030303-101CS1P-N
29
8
TT 0146
LT
1/4" D
D 1/4"
3/4"-HFO-011030107-101SD0P-S
CLOSED
NOTE 4
L5A
0047
MIN. 32
L4A
2" 2"
LG
PIPING INST.
33
PIPING
2" 2" 1/4" D
ID 24"
M5
INST.
0048
MAG
L4B
L5B
INST.
MIN.
35
PIPING
L6B
37
TI 0201
DE
2"-HFO-011039105-101CL4P-S
36
38
ZC 0357
IA
PIPING 2" 2"
101CM2P 101CS1P
INST.
MIN.
1/4" BY PIPING BY INST.
37
40
ES
NOTES 7, 9
3m
41
RESET
ZHXS 3/4"
38
0081 L
TRIM: HFO-011030602-103SD0P / HFO-011030101-103CL4P / HFO-011030102-103CM4P / HFO-011030103-101CL4P INSULATION: H
NC
NOTE 3
ES
28"-HFO-011030001-101CL2P-S
101CH2F 101SD0P
NOTE 6
ZHXS
6"-HFO-011039008-101SD0P-S
2107
011-C-0003 VACUUM COLUMN
101CM2P 101CS1P
3 m MIN.
39
29
DIAPHRAGM SEAL + AS PER PIPING CLASS SPEC. ADAPTER
HPT
3/4"-LFL-011030302-101CH2F-N
CL300
DETAIL "A" 40
DETAIL "C" 011-C-0003
MIN.
41
3- LOCAL EMERGENCY SWITCH BEHIND FIREWALL OR IN SAFE LOCATION. 4- ENSURE THAT NOZZLES FOR LEVEL TRANSMITERS ARE AT THE SAME ELEVATION. 5- DESIGN TO BE CAREFULLY MADE ON VDU FURNACE OUTLET TO AVOID EROSION PHENOMENA FOR THE REDUCTION AND ELBOWS UP TO TRANSFER LINE. 6- CONNECTION ON TOP OF PIPE. 7- FOR NOZZLES DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING. 8- OP.TEMP °C TOP/BOTTOM : 80/360 FLASH ZONE TEMP : 396°C. OP. PRESS (barg) TOP / BOTTOM: -0.89 / -0.83. 9- FOR INSTRUMENTS NOZZLES (EXCEPT TEMPERATURE INSTRUMENTS) SEE DETAIL "C". 10- CHECK VALVE AND ISOLATION VALVE ARE TO BE CLOSE TO THE COLUMN AT THE SAME PLANE OR ABOVE OF THE NOZZLE. 12- LEVEL INDICATION TO BE CONSIDERED ONLY IN CASE OF VDU BY-PASS. 13- DELETED.
REV
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
FLO FLUSHING OIL
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM COLUMN BOTTOM
Project:
011-074 011-076 011-075 011-080
Item Tags :
011-C-0003
Syst./ S-Syst.:
011-077
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480081 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480081 2271-011-PID-0021-030
REV: 05
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
41
40
011-E-0025-A / B PRECONDENSER
40
INSULATION (SHELL / TUBE): P / N
39
NOTE 2
39 38
AI
AI
0035
0035
CMS
CORROSION INST. PIPING 2" AT
NOTE 10
37
38
1"D2" 11.00
0035
+
2"-PRO-011031004-103CH4S-P
2"
36
CL300
60"-PRO-011030002-101CH4S-P 35
TT
TI
0167
0167
37
TZV 0003 +
36
2"-CWR-011032001-101CS1P-N
60"-PRO-011030002-101CH4S-P
CL300
NOTE 1 MIN.
34
35
2"x1"
MIN.
34
3/4"
33
V FB NOTE 9 LO
60"
60"
32
MIN.
32
33
2"-CWA-011032004-101CS1P-N
31
31
28"-PRO-011031001-101CH4S-H
28"-PRO-011031001-101CH4S-H
30
VACUUM TO 011-E-0025C/D
4083
MIN.
29
29
28"-CWA-011031001-101CS1P-N
TI 0149
3/4"
3/4"
0151
0164
0164
26 25 24 23 22
S2
T2
011-E-0025-A NOTES 5,11,13
S3
T1
16"
18"x16" 16"
S1
17 16
16"x14" S4
S5
T1
4"
16" 1"D2" 11.00
26000 mm NOTE 4
16"x14"
14
60"x46"
20
46"x36"
19
CL300
36"
T2
15
TI
2"
46"x36"
18"x16" 16"
18
TI 0152
60"x46"
CL300 16"x14"
19
CL300
TT
21
2"
TI
20
16"x14"
+
36"
S4
S1 S2 16" S3 4"
18
011-E-0025-B NOTES 5,11,13
S5
4"
TZV 0014 +
9
2"
12
V
TI
CL300
0341
FB NOTE 9 LO
4"x3" CP
2"-CWS-011031001-101CS1P-N
NOTE 7 011-SP-0159
7
28"-CWS-011031301-101CS1P-N
4
FI
FT
0065
0065
2"-CWS-011031006-101CS1P-N
1/2"
5
CL300
26"-PRO-011031002-101CH4S-H NO POCKET
3
3"-AWS-011031001-101CH4S-N NOTE 3
1
28"-PRO-011032021-101CH4S-P
60"-PRO-011030002-101CH4S-P
2
NO POCKET
INST. PIPING
28"-CWS-011031301-101CS1P-N
1/2"
3
11
2"
TI
CL300
10
0342 9
4"x3"
8
28"-CWS-011031301-101CS1P-N
1
CONDENSATE
VDU OVERHEAD
FROM 011-C-0003
FROM 011-J-0001A-C
TO 011-D-0008
TO 011-J-0001
TO 011-D-0008
DS011-TRJR-480080 3317
DS011-TRJR-480084 6179
DS011-TRJR-480086 3375
DS011-TRJR-480084 3376
DS011-TRJR-480086 3377
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JVM / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MRM / FCB
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES
NOTE 14 EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C NOTE 12 DES.PRESS. barg DES.TEMP. °C SURFACE m² DUTY Gcal/h
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
SHELL/TUBE SHELL/TUBE
011-E-0025-A / B AXS 6.00 -0.90 80.00 36.50 47.50 40.80 3.50 11.00 300.00 80.00 3064.6 NOTE 15 3.80
NOTE 16
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
6 DELETED. 1- SYMMETRICAL ARRANGEMENT. 2- THE TWO LINES BETWEEN 011-C-0003 TOP AND 011-E-0025A/B/C/D TO BE IDENTICAL. FOR EACH OF THEM THE DISTRIBUTION FOR THE PRECONDENSER INLET NOZZLES HAS TO BE SYMMETRICAL. 3- VERTICAL LINES BETWEEN 011-E-0025A/B/C/D AND 011-D-0008 (OR WITH A MAXIMUM ANGLE OF 45º FROM VERTICAL LINE). A VERTICAL STRAIGHT RUN OF 5 PIPE DIAMETERS OR 1,2m BEFORE EACH CHANGE OF DIRECTION OR REDUCER IS REQUIRED. 4- 15 METERS MINIMUM ABOVE UPPER TANGENT LINE OF DRUM 011-D-0008. BAROMETRIC LEG WILL BE 16.7m. 5- VENT TO BE PROVIDED AT HIGH POINT (TUBE SIDE/SHELL SIDE) FOR ALL ISOLABLE EXCHANGERS GROUP. 7- CORROSION PROBE. 8- AT GRADE. AT SAFE LOCATION. 9- GATE VALVE SHALL BE INSTALLED WITH STEM IN OR BELOW THE HORIZONTAL POSITION. 10- CORROSION MONITORING SYSTEM. 11- FOR DETAILS REFER TO VENDOR DRAWING SA-JER-DS011-DSAW-270011. 12- OUTLET SHELL SIDE TEMPERATURE IS CONDENSATE TEMPERATURE. 13- PRECONDENSERS ARE PART OF VACUUM SYSTEM PACKAGE 011-X-0001. 14- OP. PRESS.: SHELL SIDE = 0.11 bara. 15- TOTAL SURFACE AREA = 3064.6 m2, SURF. PER SHELL: 766.1 m2. 16- FULL VACUUM ON SHELL AND TUBE SIDE AT 300ºC AND 80ºC RESPECTIVELY.
DATE
UTILITIES IDENTIFICATION 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
6
2
CONDENSATE
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001).
4088
3
NOTE 8
POS.
7
4
4702
GENERAL NOTES
COOLING WATER SUPPLY TO 011-E-0025C/D
5
OFF GAS
VDU OVERHEAD
14
CL300
3/4"
8
6
15
NOTE 3
10
2"x1"
3"-AWS-011031002-101CH4S-N
11
16
13
14"-CWS-011031003-101CS1P-N
12
17
2"-CWS-011031006-101CS1P-N
MIN.
14"-CWS-011031002-101CS1P-N
13
28
V
V
21
2"
MIN.
22
MIN.
23
4086
2"-CWR-011032001-101CS1P-N
24
TT 0149
COOLING WATER TO 011-E-0025C/D
27
26000 mm NOTE 4
25
2"
18"-PRO-011031001-101CH4S-H
26
18"-PRO-011031001-101CH4S-H
14"-CWA-011031002-101CS1P-N
27
14"-CWA-011031003-101CS1P-N
28"-CWA-011031001-101CS1P-N
28
30
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PRE-CONDENSER
011-074 011-076 Item Tags :
011-075 011-080
011-E-0025-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480082 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480082 2271-011-PID-0021-031
REV: 05
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
011-E-0025-C / D PRECONDENSER
40
40
INSULATION (SHELL / TUBE): P / N
39
39
NO POCKETS
38
26"-PRO-011031003-101CH4S-H
VDU OVERHEAD TO 011-J-0001
4098
NOTE 2
37
NO POCKETS
36 35
TI
TT
0159
0159
60"-PRO-011030001-101CH4S-P
37 4099
36
2"
35
CL300 TI 0150
NOTE 1
34
TO 011-J-0001 VDU OVERHEAD
26"-PRO-011031001-101CH4S-H
38
MIN.
MIN.
34
33
33
32
32
30
TT 0150
PI 0378
31
31
28"-PRO-011031001-101CH4S-H
VACUUM
30
4083FROM 011-E-0025A/B
INST.
MIN. 29
PIPING
COOLING WATER
2" CL300
3/4"
29
28"-CWA-011031001-101CS1P-N
27 26 25 24
2"
TT 0115
CL300
28
14"-CWA-011031005-101CS1P-N
14"-CWA-011031004-101CS1P-N
28 4086FROM 011-E-0025A/B
TI 0115
27 26 25
2" CL300
TT
TI
0158
0158
24 23
22
22
3/4"
3/4" 60"
19
16
TI 0154
46"x36" 18"x16" 36"
T2
S4
S2 S1
2"
19
CL300 16"x14"
46"x36" 18"x16"
16"
011-E-0025-C
T2
S3
16"
S5
4"
16"
14
16"x14"
17
NOTES 7, 8 S3
T1
S5
4"
16
NOTE 9
16" 15
26000 mm NOTE 4
15
S4
S1 S2
NOTE9
18
011-E-0025-D
36"
NOTES 7, 8 T1
20
60"x46"
26000 mm NOTE 4
17
CL300 16"x14"
60"x46"
16"
NO POCKETS
18
2"
18"
TI 0153
V
60"
V 20
21
18"
21
MIN.
MIN.
23
16"x14"
14
10 9 8 7
4088
2"
TI
CL300
0343 NOTE 13
4"x3"
14"
11
2"
TI 0344
CL300 4"x3"
28"-CWS-011031301-101CS1P-N
COOLING WATER SUPPLY FROM HEADER
MIN. NOTE 3
5
10 9 8 7 6
NOTE 3
6
28"-PRO-011032021-101CH4S-P
11
12
28"-CWA-011031001-101CS1P-N
12
14"-CWS-011031005-101CS1P-N
13
14"-CWS-011031004-101CS1P-N
13
5
4
4
3
3
VDU OVERHEAD
CONDENSATE
04
30-SEP-2011
03
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
CONDENSATE
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
RDP / MAC
JAL
IFD: ISSUED FOR DESIGN
ARV / STG
RDP / MAC
JAL
11-DEC-2009
IFD
REV
DATE
COMPANY STATUS
1- SYMMETRICAL ARRANGEMENT. 2- THE TWO LINES BETWEEN 011-C-0003 TOP AND 011-E-0025A/B/C/D TO BE IDENTICAL. FOR EACH OF THEM THE DISTRIBUTION FOR THE PRECONDENSER INLET NOZZLES HAS TO BE SYMMETRICAL. 3- VERTICAL LINES BETWEEN 011-E-0025A/B/C/D AND 011-D-0008 (OR WITH A MAXIMUM ANGLE OF 45° FROM VERTICAL LINE). A VERTICAL STRAIGHT RUN OF 5 PIPES DIAMETERS OR 1,2m BEFORE EACH CHANGE OF DIRECTION OR REDUCER IS REQUIRED. 4- 15 METERS MINIMUM ABOVE UPPER TANGENT LINE OF DRUM 011-D-0008. 011-E-0025-C / D AXS -0.90 6.00 80.00 36.50 47.50 40.80 3.50 11.00 300.00 80.00 3064.6 NOTE 11 3.78
NOTE 10 NOTE 12
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
7- FOR DETAILS REFER TO VENDOR DRAWING SA-JER-DS011-DSAW-270011. 8- OUTLET SHELL SIDE TEMPERATURE IS CONDENSATE TEMPERATURE. 9- PRECONOENSERS ARE PART OF VACUUM SYSTEM PACKAGE. 011-X-0001. 10- OP. PRESS: SHELL SIDE= 0.11 bar. 11- TOTAL SURFACE AREA= 3064.6 m2, SURF PER SHELL: 766.1 m2. 12- FULL VACUUM ON SHELL AND TUBE SIDE AT 200ºC AND 80ºC RESPECTIVELY. 13- CONNECTION FOR FLUSHING
UTILITIES IDENTIFICATION 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
1
JAL
00
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
2
FROM 011-J-0001-A-C
AVS / HCR
TO 011-D-0008
DESCRIPTION
6173
MJR / STG
DS011-TRJR-480086 3397
POS.
OFF GAS
AB: AS BUILT
TO 011-D-0008
5,6 DELETED.
SHELL/TUBE SHELL/TUBE
AB
DS011-TRJR-480086 3394
NOTES
IN/OUT IN/OUT
13-MAR-2013
FROM 011-C-0003
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
SHELL/TUBE SHELL/TUBE
05
DS011-TRJR-480080 8966
GENERAL NOTES
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C NOTE 8 DES.PRESS. barg DES.TEMP. °C SURFACE m² DUTY Gcal/h
COOLING WATER TO 011-E-0026/E-0027/ E-0028 DS011-TRJR-480085 3392
3"-AWS-011031004-101CH4S-N
1
3"-AWS-011031003-101CH4S-N
60"-PRO-011030001-101CH4S-P
2
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PRE-CONDENSER
011-074 011-076 Item Tags :
011-075 011-080
011-E-0025-C/D
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480083.pid
Discipline: PRO
SA-JER-DS011-TRJR-480083 2271-011-PID-0021-031
REV:
05
Sheet: 2 of 2
SCALE: NONE Format:
A1
INSULATION: P
INSULATION: H
011-J-0002-A / B/ C SECOND STAGE OF VACUUM SYSTEM
PI
ZC 0418
0076
INSULATION: P
ZYV 0017
39
VDU OVERHEAD 4099FROM 011-E-0025
VDU OVERHEAD
36
H
TI 0155
37
INST. PIPING
26"-PRO-011031003-101CH4S-H
4098FROM 011-E-0025
0381
+
ATM
8" B1
011-D-0024
33
0381
PV 0381
+
FC TSO
INSULATION: P
40
FT
38
0151
ZV 0017
35 34
PT
IA
2"
0151
41
39
PC
DE
TT 0155
L
ZHSR 0017
S
PT 0076
26"-PRO-011031001-101CH4S-H
3/4"
37
INST. PIPING
CLOSED
OPEN
ZLC 0017
ZLO 0017
POSITIONER BY-PASS ZYC 0017
8"-MPS-011032001-103CS1P-H 35
FO TSO
3/4" D
ZHA 0017
34
8"x6"
6"
33
8"x6"
A1
ZY
ZHS
0017 C
0017 O
0017
0017
8" ID
29
PIPING 1"
PI 26
INST.
PIPING 1"
PI
0494
B2
3/4"
V
2"
2" 2"
LG 0116
0495
INST.
PIPING
LT 0117
1/4" 2"
LI 0117
H
Z 0004
2" 25
2"x1" 1"
1/4" INST. PIPING
23 22
2"-MPS-011032302-103CS1P-H
-H 1P CS 03 2 -1 01 32 10 -01 PS -M
D
" 3/4
3/4"
24
8"-MPS-011032002-103CS1P-H
2"-MPC-011032301-103CS1P-H
24
3/4" D 3/4"
23
2"x3/4"
3/4"
26"x24"
2"x1-1/2" M1
3"
3"
24" J1
011-J-0001-B
NOTES 2,3,4,6 J2
13
18"
011-J-0001-C
18"
J2
6" 10"x6"
20"x18"
PI 0075
8 7
8"-PRO-011032009-101CH4S-H
1"
LO
20"-PRO-011032008-101CH4S-P
PIPING INST.
20"-PRO-011032007-101CH4S-P
10 9
LO
20"-PRO-011032006-101CH4S-P
11
011-J-0002-A NOTES 2,3,4,6
8"x6"
1-1/2" M11
1-1/2" M11 8"x6"
011-J-0002-B NOTES 2,3,4,6
6" J11
PI 0104 INST. PIPING
6
J12
6" 10"x6"
LO
MIN.
21
3/4"
3/4"
3/4"
20
1-1/2" M21 6"x4"
1-1/2" 6"x4" M21
NOTES 2,3,4,6
NOTES 2,3,4,6
J12
6" 10"x6"
J12
PI
LO
LO
J22 4"
8"x4"
6" J11
LO
1"
D
3"x1-1/2"
011-J-0003-A
011-J-0002-C
18"
J2
12
LO
2"x1-1/2"
2"x1-1/2"
6" J11
NOTES 2,3,4,6
NOTES 2,3,4,6
20"x18"
20"x18"
24" J1
8"x6"
1-1/2" M11
D
3"x1-1/2"
4" J21 LO
0105 INST. PIPING
1"
LO
011-J-0003-B NOTES 2,3,4,6
4" J21
MIN.
4"
J22
8"x4"
LO
6"x4"
1-1/2" M21
6173
26"-PRO-011031002-101CH4S-H
1
LO
4"
15
8"x4" 14
LO 8"-PRO-011032020-101CH4S-P 10"-PRO-011032005-101CH4S-P
13
VACUUM TO 011-E-0028
4101
12 11
LO
10
MIN.
9 8
MIN.
8"-PRO-011032004-101CH4S-H NO POCKETS
VACUUM FROM 011-E-0027
18"-PRO-011032003-101CH4S-P NO POCKETS
VACUUM TO 011-E-0027
12"-PRO-011032002-101CH4S-H NO POCKETS
VACUUM FROM 011-E-0026
32"-PRO-011032001-101CH4S-P NO POCKETS
VACUUM TO 011-E-0026
7 4102
6 4103
5 4
4104
3 2
4105
1
+
14" 20"x14"
28"x14"
28"-PRO-011032021-101CH4S-P NO POCKETS
FC TSO
MIN. 28"-PRO-011032021-101CH4S-P
28"x14" 1"-PRO-011032022-101CH4S-P
MIN.
14" 20"x14"
20"-PRO-011032021-101CH4S-P NO POCKET HPT 29
NC
DS011-TRJR-480082 3376
DS011-TRJR-480082 6179
5032
011-J-0001-A / B/ C 2112.0 13.20 270.00 19.00 300.00
011-J-0002-A / B/ C 2112.0 13.20 270.00 19.00 / FV&3.5 300.00
011-J-0003-A / B/ C 2112.0 13.20 270.00 19.00 / FV&3.5 300.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
NOTE 5
SIGNAL
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
DFI / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
VJS / FCB
RDP / MAC
JAL
PREPARED BY
CHECKED BY
FROM 011-PC-0072
DS011-TRJR-480081
1"-LFL-011032302-101CH2F-N
6182
NC
GENERAL NOTES
011-D-0024 VERTICAL 1900.0 700.0 14.00 250.00 19.00 +FV 350.00
101CH4S 101CH2F
TO 011-E-0025 A/B
MIN.
VDU-OVERHEAD FROM 011-E-0025-A/B
EJECTORS NUMBER OF STAGES C.W. CONSUMP. Nm³/h STEAM CONSUMP. kg/h IN.OP. PRESS. barg IN. OP. TEMP. °C NOTE 7 DES. PRESS. barg DES. TEMP. °C
J22
PV 0072
OFF GAS
mm mm barg °C barg °C
17 16
LO
3/4"
DRUM TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
18
NOTES 2,3,4,6
MIN.
OFF GAS TO 011-E-0025 C/D
011-J-0003-C
4" J21
4
2
19
3"x1-1/2"
5
3
22
3"-MPS-011032010-103CS1P-H
D
8"-PRO-011032018-101CH4S-P
011-J-0001-A
14
3/4 "
LO
LO 24" J1
" 3/4
6"-PRO-011032015-101CH4S-H
LO
D
D
D
" 3/4
10"-PRO-011032014-101CH4S-P
15
3/4"
M1
3"
2"-MPS-011032007-103CS1P-H
8"-PRO-011032011-101CH4S-H
LO M1
26"x24"
26"x24"
D
3"-MPS-011032009-103CS1P-H
3"-MPS-011032013-103CS1P-H
2"-MPS-011032008-103CS1P-H
10"-PRO-011032013-101CH4S-P
16
3/4"
3"-MPS-011032006-103CS1P-H
8"-PRO-011032010-101CH4S-H
17
D
28
13
NC
D
29
25
2"x1"
3/4" D 2"x3/4"
2"-MPS-011032012-103CS1P-H
30
6398
3/4" D
10"-PRO-011032012-101CH4S-P
18
3"-MPS-011032005-103CS1P-H
3"-MPS-011032011-103CS1P-H
19
31
26
21 20
32
27
6"-PRO-011032017-101CH4S-H
INST.
27
EL. 14000 mm
28
8"-PRO-011032019-101CH4S-P
H1
ZLS
6"-PRO-011032016-101CH4S-H
8"
2187
30
ZLS
8"-MPS-011032002-103CS1P-H
8"-MPS-011032301-103CS1P-H
10
6"-MPS-011032004-103CS1P-H
NC
32 31
36
MIN.
8"
4"-MPS-011032003-103CS1P-H
38
+
FI
011-J-0003-A / B / C THIRD STAGE OF VACUUM SYSTEM
RESET
1/2"
011-D-0024 MOTIVE STEAM POT
1/2"
40
011-J-0001-A / B / C FIRST STAGE OF VACUUM SYSTEM
3/4"
41
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 1 FIRE WATER 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER 4 POTABLE WATER NOTES 5 DEMI WATER 1 DELETED. 6 N.A. 2- EJECTORS ARE PART OF VACUUM SYSTEM PACKAGE 011-X-0001. 3- LOCKED OPEN DISCHARGE VALVES PROVIDED TO ENSURE THAT THE OFFLINE EJECTOR IS NOT OVERPRESSURIZED BY THE MP STEAM. 7 N.A. 4- OPERATING INSTRUCTIONS REQUIRED TO ENSURE THAT MP STEAM LINE CAN NOT BE OVERPRESSURIZE AN EJECTOR AND PIPE WORK. 8 N.A. 5- MAKE CONNECTIONS ON TOP OF THE LINE. 9 HP STEAM 6- FOR DETAILS REFER TO VENDOR DRAWINGS: 10 MP STEAM SA-JER-DS011-DSAW-270012 SA-JER-DS011-DSAW-270014 11 LP STEAM SA-JER-DS011-DSAW-270015 12 HP CONDENSATE 7- DES. PRESS OF EJECTOR / MOTIVE. 13 MP CONDENSATE 14 LP CONDENSATE 15 BFW 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A.
REV
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
DESCRIPTION
19 N.A. 20 FUEL OIL 21 FUEL GAS 22 N.A. 23 N.A. 24 N.A. 25 CLOSED DRAIN 26 N.A. 27 L.P. NITROGEN 28 H.P. FLARE 29 L.P. FLARE 30 SOUR/ACID FLARE 31 PILOT GAS 32 AUX COOLING WATER FLO FLUSHING OIL AMD AMINE CLOSED DRAIN CND TURBINE CONDENSATE
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080 011-077 011-079 011-071
Item Tags : 011-D-0024
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM SYSTEM EJECTORS 011-J-0001-A/B/C
011-J-0002-A/B/C
011-J-0003-A/B/C
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480084.pid
Discipline: PRO
SA-JER-DS011-TRJR-480084 2271-011-PID-0021-032
REV:
05
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
40 39
011-E-0026 1ST STAGE CONDENSER
011-E-0027 2ND STAGE CONDENSER
011-E-0028 3RD STAGE CONDENSER
INSULATION ( SHELL / TUBE ) : P / N
INSULATION ( SHELL / TUBE ) : P / N
INSULATION ( SHELL / TUBE ) : P / N
40
CONDENSATE TO 011-D-0008 CONDENSATE TO 011-D-0008 CONDENSATE TO 011-D-0008
38 37
NO POCKET
39 4124 4125 4126
36
38 37 36
NO POCKET
TI
TT
0036
0036
2" CL300
29
32"
24" T12
28
2" CL300
S14
S11
NOTE 1 26000 mm
25 24
S15
6"
24"
0156
0156
10" T22
011-E-0026
CL300
12"x10"
TT
TI
0157
0157
TI
TT
0160
0160
S24
S21
0161
22
2"
2"
CL300
CL300
3/4"
TW 0346
CL300
NOTE 11
0162
S32
0038
0038
33 32 31 30 29 28
S34
S31
S33
011-E-0028 NOTE 8
27
NOTE 11
26
S35
2"
10" 12"x10"
25
4"x2"
24
TI
2"
TI
TI
6"
6"
T31
S25
2"
CL300
CL300 2" 3/4"
TW 0347
4"x3"
3/4"
TW
0163
23
0348
CL300 4"x2" 2"
22
V 2"-AWS-011032003-101CH4S-N
21
V
MIN.
V
MIN.
21
2"
CL300
TT
NOTE 8
8" S22
S23
011-E-0027
2"
34
10"x6"
T32
MIN.
TI
CL300 2"
12"x10"
4"x2" 23
1"
10"
10"
6"x4"
CL300
12"
T21
NOTE 11
2"
18"x12"
NOTE 8
12" S12
S13
T11
TI
0037
12"x10"
27 26
TT
0037
0077
4"-AWS-011032001-101CH4S-N
NO POCKET
TT
PI
3"-AWS-011032002-101CH4S-N
32"-PRO-011032001-101CH4S-P
31 30
12"-PRO-011032002-101CH4S-H
32
TI
2"
NOTE 1 26000 mm
NO POCKET
8"-PRO-011032004-101CH4S-H
33
INST. PIPING 18"-PRO-011032003-101CH4S-P
NO POCKET
NOTE 1 26000 mm
34
2"-AWS-011032003-101CH4S-N
35
10"-PRO-011032005-101CH4S-P
35
3"-AWS-011032002-101CH4S-N
20
20
19
19
12
RO 0073
VACUUM 4102 TO 011-J-0003
10 Ø MIN.
10ø MIN.
8"-PRO-011032004-101CH4S-H
2" 18"-PRO-011032003-101CH4S-P VACUUM 4103FROM 011-J-0002
CL300
12"-PRO-011032002-101CH4S-H
VACUUM 32"-PRO-011032001-101CH4S-P 4105FROM 011-J-0001
1
3/4"
IN/OUT IN/OUT
SHELL/TUBE SHELL/TUBE
6 5
0380 4 3 OFF GAS
2
DS011-TRJR-480089 3389
1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR/ STG
AVS / MAC
JAL
COOLING WATER
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MCG/ STG
RDP / MAC
JAL
FROM 011-E-0025
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MMG / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
NOTES
SHELL/TUBE SHELL/TUBE
7
4704
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001) 2- FOR GENERAL NOTES,SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER DSAAA-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
011-E-0027 AXS -0.53 5.18 139.80 40.80 72.00 44.20 3.50 11.00 300.00 80.00 174.4 1.14
8
PI
3
GENERAL NOTES
011-E-0026 AXS -0.78 5.18 131.50 40.80 61.60 45.00 3.50 11.00 300.00 80.00 871.9 7.18
TI 0165
9
TO 011-D-0009
DS011-TRJR-480083 3392
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C NOTE 10 DES.PRESS. barg DES.TEMP. °C SURFACE m² DUTY Gcal/h
TT 0165
10
6"-GAS-011032001-101CH4S-P
28"-CWR-011032301-101CS1P-N
VACUUM 4104 TO 011-J-0002 4
2
11
+
5
3
14
28"-CWR-011032301-101CS1P-N
6
15
13
28"-CWA-011031001-101CS1P-N
7
16
MIN.
10"-PRO-011032005-101CH4S-P VACUUM 4101FROM 011-J-0003
10
8
17
20"-CWR-011032002-101CS1P-N
11
9
D
18
PIPING INST.
12
28"-CWA-011031001-101CS1P-N
12"-CWA-011032003-101CS1P-N
14
2"
12"-CWR-011032304-101CS1P-N
15
12"-CWA-011032002-101CS1P-N
16
12"-CWR-011032303-101CS1P-N
24"-CWR-011032302-101CS1P-N
17
13
24"-CWA-011032001-101CS1P-N
4"-AWS-011032001-101CH4S-N 18
011-E-0028 AES 0.32 5.18 178.40 40.80 96.80 45.00 3.50 11.00 300.00 80.00 85.4 1.34
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
3,4,5,6,7,14 DELETED 1- 15 METERS MINIMUM ABOVE UPPER TANGENT LINE OF DRUM 011-D-0008. 2- DELETED. 8- FOR DETAILS REFER TO VENDOR DRAWINGS SAJER-DS011-DSAW-270013. SA-JER-DS011-DSAW-270015,SA-JER-DS011-DSAW-270017. 9- SHELL SIDE DESIGN TEMPERATURE SHALL BE 350ºC EXCEPT FOR DUPLEX MATERIAL FOR WHICH THE DESIGN TEMPERATURE SHALL BE 315ºC. 10- OUTLET SHELL SIDE TEMPERATURE IS CONDENSATE TEMPERATUR. 11- 011-E-0026, 011-E-0028 ARE PART OF VACUUM SYSTEM PACKAGE 011-X-0001. 12- OP. PRESS ( SHELL / TUBE ) : 011-E-0026 = 176 mmHgabs / 011-E-0027 = 366 mmHgabs / 011-E-0028 = 1000 mmHgabs. 13- FULL VACUUM ON SHELL AND TUBE SIDE AT 300ºC AND 80ºC RESPECTIVELY. NOTE 12 NOTE 13 NOTE 9
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM SYSTEM CONDENSERS
011-074 011-076 011-075 011-080
Item Tags :
011-E-0026
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
011-E-0027
011-E-0028
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480085 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480085 2271-011-PID-0021-032
REV: 05
Sheet: 2 of 2
SCALE: NONE Format:
A1
011-D-0008 VACUUM SYSTEM RECOVERY DRUM
41
CONDENSATE 4124FROM 011-E-0028 CONDENSATE 38 4125FROM 011-E-0027
2"-AWS-011032003-101CH4S-N
CONDENSATE 4126FROM 011-E-0026
4"-AWS-011032001-101CH4S-N
2"-AWS-011032003-101CH4S-N
+
40
LO FB
0.2 %
10"-LFL-011033301-101CH2F-N
SIGNAL
NOTE 4
29
NOTE 1
CL300 10"x6"
3"-AWS-011032002-101CH4S-N
3"-AWS-011032002-101CH4S-N
3/4" V 10"x8"
PZV 0024
TO 011-FC-0152 / 0153
2060
6"Q8" 1.89
4132
2"
NOTE 8
4"-AWS-011032001-101CH4S-N
+
NOTE 3
35
37
3/4" V 10"x8"
PZV 0025
36
10"-LFL-011033307-101CH2F-N
NOTE 1 FB LO
CL300 10"x6"
3"-AWS-011031001-101CH4S-N
1"
34
32
3"-AWS-011031003-101CH4S-N
3"-AWS-011031004-101CH4S-N
NC
MIN.
23
PUMP STOP
LI 0055
1" 22
ZC 0354
011-D-0008
MIN.
21
PIPING INSTR.
A11
INST. PIPING 2"
19 18
L3B
LG
LT
LT
0056
0055
0057
24" ID
2"
2"
17
PIPING
1/4" D
16
2"-PRO-011033023-101CH2S-P UC
15
INST. PIPING
13 12 11 10 9
LC 0057
8
H
1" V NC MIN.
3/4"-PRO-011033010-101CH2S-N
14
L3A
2" S1
1/4" D
L2A
1"
A9 2"
A4 3"
A3 A10 3" 2"
E1 4"
23 22
2" P1 W1 2" 10"
V 4"
A2 3"
A1 3"
PIPING INST.
2"
2"
2"
1/4"
L4A
L1A
L5A
M2
2"
1/4" D
21
LI 0058
2"
2" D L6B
2" 2"
2"
PIPING INSTR.
1"x3/4"
2"
L4B
2"
L5B 1/4"
20
LL
D
ID 24"
ZC 0353
PUMP STOP
19
MAG LT
LT
LG
0060
0058
0059
18
2"
L6A
17
PIPING INST.
1/4" D
16
2"-AWS-011033023-101CH2S-P B1
D3
3"
6900 mm
INST.
A6 A5 3" 4"
2"
2"
25 24
1"-AWS-011033301-101CH4S-N
PIPING INST.
2"
26
101CH2F 101CH4S
NC
PIPING 2"
29
NOTE 4
2" L2B 1/4" D
INST.
M1
1"-LFL-011033302-101CH2F-N
2061
2"
2"
1/4" D
MAG
HPT
4" V A7 2"
2" L1B
2"
20
28 27
NOTE 5 2"
LL
29 RECOVERED OIL FROM 011-G-0020-A/B 6183
NOTE 2
NOTE 4
3/4"-AWS-011033302-101CH2S-N 101CH2F 101CH2S
24
30
A8
D2
3" 3"-AWS-011033022-101CH2S-N 101CH2S 101CS1P
2" 2"-PRO-011033018-101CH2S-N 101CH2S 101CS1P
S2 2"
D1
B2
2"
2"
8"
1" 101CH2S 101CS1P
V
NC
2"-OLW-011033301-101CS1P-N 3"x2"
INSTR. PIPING
MIN. 2"-AWS-011033020-101CH2S-N
2"-OLW-011033303-101CS1P-N
15
UC
3"-OLW-011033302-101CS1P-N
OLW
H
LC 0060
L
4"-GAS-011033001-101CH4S-N
2062
31
2"-AWS-011034001-101CH2S-N
29
25
PI 0078
PIPING INST.
3/4"-LFL-011033303-101CH2F-N
32
NOTE 2
2"-PRO-011033024-101CH2S-N
HPT
NOTE 4
29 6738
4"-GAS-011033001-101CH4S-N
2"-AWS-011036001-101CH2S-N
26
33
1"-LFL-011033306-101CH2F-N
MIN.
27
2"
10"-GAS-011033002-101CH4S-N
28
34
V
2"-PRO-011033003-103CH2S-N
101CH2S
29
35
10"
103CH2S
30
36
1"
1" 1" D
FB LC
NOTE 4
29 6737
101CH2F 101CH4S
MIN.
31
011-SP-0030 NOTE 1
NOTE 1
FB LO
0.2 %
101CH4S 101CH2F
1"
3"-AWS-011031002-101CH4S-N
NC
1"
1" D 33
14 13 12 11 10 9
L
8
7
7
6 5
RECOVERED OIL TO 011-G-0020 A/B
3"-PRO-011033001-101CH2S-N
3"-PRO-011033001-101CH2S-N 2"-AWS-011033012-101CH2S-N
2906
25
3"-CLD-011033308-101CH2S-N
CONDENSATE
CONDENSATE
SOUR WATER
SOUR WATER TO 011-G-0019A/B DS011-TRJR-480088 3420
FROM 011-E-0025A
FROM 011-E-0025B
FROM 011-E-0025C
FROM 011-E-0025D
FROM 011-D-0017
FROM 011-D-0009
DS011-TRJR-480082 3375
DS011-TRJR-480082 3377
DS011-TRJR-480083 3394
DS011-TRJR-480083 3397
DS011-TRJR-480093 3405
DS011-TRJR-480089 3410
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
DRUM TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
mm mm barg °C barg °C
011-D-0008 HORIZONTAL 7100.0 3100.0 0.30 50.00 3.50 NOTE 6 250.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
101CH2S 101CS1P
2904
SOUR WATER
GENERAL NOTES
4131
25
OLW CONDENSATE
DS011-TRJR-480088
OLW
2905 CONDENSATE
MIN.
3"x3/4"
05
13-MAR-2013
AB
1 2 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 3 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 4 NOTES 5 7 DELETED. 6 1- GATE VALVE SHALL BE INSTALLED WITH STEM IN OR BELOW THE HORIZONTAL POSITION. 7 2- EQUILIBRIUM LINE. 8 3- MECHANICAL LINK. 9 4- MAKE CONNECTION ON TOP OF LINE. 10 5- FOR NOZZLES DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING. 6- FULL VACUUM AT 100ºC. 11 8- SET PRESSURE READJUSTED BASED ON A ELEVATION FROM TOP TL OF 011-D-0008 TO PZV. ELEVATION DIFFERENCE SHOULD NOT BE HIGHER THAN 16.6m 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
SOUR WATER
VENT GAS
FROM 011-J-0004
TO 011-D-0009
DS011-TRJR-480090 3423
DS011-TRJR-480089 3411
2 1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
DFI / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JVM / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS.
SIGNAL TO 011-LV-0060
250mm MIN.
8"-AWS-011033001-101CH2S-N
2"-CLD-011033307-101CH2S-N
25
3/4"-OLW-011033305-101CS1P-N
2"x3/4"
3/4"-OLW-011033310-101CS1P-N
2"-CLD-011033301-101CH2S-N
MIN.
MIN.
MIN.
4
MIN.
250mm MIN.
OLW
5
3
101CS1P 101CH2S
2"-AWS-011036001-101CH2S-N
3"-AWS-011031004-101CH4S-N
3"-AWS-011031003-101CH4S-N
3"-AWS-011031002-101CH4S-N
3"-AWS-011031001-101CH4S-N
2
4130
MIN.
2"x3/4"
250mm MIN.
101CS1P 101CH2S
3
6
LPT
MIN.
2"-AWS-011034003-101CH2S-N
3/4"-OLW-011033304-101CS1P-N
4
1
39 38
+
3/4"-AWS-011033013-101CH2S-N
37
NOTE 8
101CH4S 101CH2F
39
+
TRIM: AWS-011033601-103CH2S / GAS-011033601-101CH4S / PRO-011033601-103CH2S INSULATION: N
40
41
6"Q8" 1.89
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM SYSTEM RECOVERY DRUM
Project:
011-074 011-076 011-075 011-080
Item Tags :
011-D-0008
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480086.pid
Discipline: PRO
SA-JER-DS011-TRJR-480086 2271-011-PID-0021-033
REV:
05
Sheet: 1 of 3
SCALE: NONE Format:
A1
41
41
40 39
40
LY
SIGNAL 4132FROM LC-0057
SPLIT RANGE
FC
0-50%
0057
39
0153
38
NOTE 12
1"E2" 14.25
38
+
50-100%
37
37
PZV 0086
3/4"
+
36
RO 0005
35
NOTE 13
3/4"
NOTE 12
1"E2" 14.25
34
3/4"-PRO-011033021-103CH2S-N TYPE 23 SC NOTE 10 011-SC-0026 3/4"-PRO-011033020-103CH2S-N 2"-PRO-011033002-103CH2S-N
29
5037
24
3"-PRO-011033001-101CH2S-N 3"-PRO-011033001-101CH2S-N
23
21 20 19
103CH2S 3/4" V
INST. PIPING
1/2"
30 29
FV 0153
1/2"
+
NOTE 6
28
2"x1-1/2"
1-1/2" 2"x1-1/2" FC
27 26
NOTE 7
3/4" FC 0152
25
2"x1-1/2" 1-1/2" 2"x1-1/2"
24
NC
3/4"-PRO-011033016-103CH2S-N
FT 0152
1/2"
1/2"
INST. PIPING
FV 0152 +
2"x3/4"
21 20
1-1/2" 2"x1-1/2" FC
103CH2S 101CH2S
3/4"
18 17
22
3/4"
2"x1-1/2"
2"-CLD-011033304-101CH2S-N
101CH2S 103CH2S
101CH2S 103CH2S
23
MIN.
MIN.
22
FT 0153
31
D
2"-PRO-011033012-103CH2S-N
25
25
FB LC
101CH2F
2"-PRO-011033006-103CH2S-N
2"-CLD-011033302-101CH2S-N 26
V
NOTE 6 011-SP-0039
6775
NOTE 8
MIN.
27
3/4"
2"-PRO-011033002-103CH2S-N
28
3/4"
FB LO
250mm MIN.
103CH2S 101CH2S
2"x1"
32
29
FB LO NOTE 6
19
2"-PRO-011033006-103CH2S-N
2"x3/4"
30
3"-LFL-011033305-101CH2F-N 0.2 %
MIN.
MIN.
3/4"
3"x2"
MIN.
MIN.
33
3/4" V
+
250mm MIN.
3/4"-PRO-011033011-103CH2S-N
PZV 0087
MIN.
V
2"-PRO-011033025-103CH2S-N
6183
2"-PRO-011033003-103CH2S-N
LPT
RECOVERED OIL TO 011-D-0008
31
2"x1-1/2" 1-1/2" 2"x1-1/2" NOTE 3
UC
15
LPT
3/4"
NC
NOTE 3
UC MIN.
25 5039
MIN.
MIN.
3/4"
NOTE 9
0079 PIPING INST.
3/4"-PRO-011033002-103CH2S-N HYDROCARBONS
3/4"
MIN. 1-1/2"
5
1"
" 3/4 1"x
3/4"
NOTE 9 LPT
M
PIPING INST.
011-G-0020-B
PIPING 3/4"
DS011-TRJR-480248 10785
NOTE 1 3"x2"
RECOVERED OIL 4130FROM 011-D-0008
0080 INST.
TO OLW
2"x1"
LPT
PI
3/4"
NOTE 1
1-1/2"
TYP. 3 MG 0020 A
103CH2S 101CH2S 2"-CLD-011033305-101CH2S-N
250mm MIN.
TO OLW DS011-TRJR-480248 10786
1" MIN.
NOTE 4
103CH2S 101CS1P
1-1/2"-PRO-011033014-103CH2S-N ZC 0354
3/4"-OLW-011033308-101CS1P-N
2"x1-1/2" 103CH2S 101CH2S
MG 0020 B
2"-CLD-011033306-101CH2S-N
OLW
NOTE 4
3/4"-OLW-011033309-101CS1P-N
OLW
25
25
2902
2907
011-G-0020-A / B RECOVERED OIL PUMPS
RECOVERED OIL TO SLOP HEADER
INSULATION: N
DS011-TRJR-480136 3428
GENERAL NOTES
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
m³/h barg bar barg °C kg/m³
011-G-0020-A / B CENTRIFUGAL 13.5 9.50 7.79 15.50 50.00 749.0
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
10 9 8 7 6 5 4 3
TYP. 3
250mm MIN.
1
5038
M
MCC 2"x1-1/2"
HYDROCARBONS
MIN.
2
ZC 0354
3/4"
103CH2S 103CS1P
250mm MIN.
MCC
MIN.
3
11
25
3"x2" " 3/4 1"x
12
D
2"x1"
103CH2S 101CS1P
1-1/2"-PRO-011033013-103CH2S-N
2"-CLD-011033303-101CH2S-N
3/4"-PRO-011033012-103CH2S-N
MIN. 4
103CH2S 101CH2S
2"-PRO-011033008-103CH2S-N
011-G-0020-A
PIPING 3/4"
PI
0262
15 14
2"-PRO-011033009-103CH2S-N
8
INST.
3/4"
PI
16
13
1-1/2"-PRO-011033014-103CH2S-N
9
PI 0252
2"x3/4"
NOTE 2
MIN.
10
3"-PRO-011033005-103CH2S-N
11
NOTE 2
1-1/2"-PRO-011033013-103CH2S-N
3"-PRO-011033001-101CH2S-N
12
2"-PRO-011033002-103CH2S-N
13
3"-PRO-011033004-103CH2S-N
MIN.
14
MIN.
3/4"-PRO-011033015-103CH2S-N
17
2"-PRO-011033026-103CS1P-N
LPT
3/4"
18
MIN.
16
6
35
NOTE 8 +
32
7
36 29
2"x1"
MIN.
33
0.2 % 6184
+
34
V
3"x2"
NOTE 6 LO FB 3"-LFL-011033304-101CH2F-N
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAIN SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER NOTES 4 POTABLE WATER 5, 11 DELETED. 5 DEMI WATER 1- PROVIDE A STRAIGHT LENGTH OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 6 N.A. 2- CHECK VALVE SHALL BE INSTALLED HORIZONTALLY. 7 N.A. 3- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 8 N.A. 4- DISMOUNTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION. 9 HP STEAM 6- GATE VALVE SHALL BE INSTALLED WITH STEM IN OR BELOW THE HORIZONTAL POSITION AS REQUIRED. 7- MECHANICAL LINK. 10 MP STEAM 8- MAKE CONNECTION ON TOP OF LINE. 11 LP STEAM 9- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JERDS011-TRJR-480248. 12 HP CONDENSATE 10- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JERDS011-TRJR-480275. 13 MP CONDENSATE 12- SET PRESSURE READJUSTED BASED ON ELEVATION FROM PIPE TOP TO PZV. ELEVATION DIFFERENCE SHOULD NOT BE HIGHER THAN 17m. 14 LP CONDENSATE 13- MULTISTEP RESTRICTION ORIFICE (6 STEPS). 15 BFW 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A.
05
13-MAR-2013
AB
04
30-SEP-2011
03
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
RECOVERED OIL
TO LP HDS
TO HP HDS
DS011-TRJR-480060 3277
DS011-TRJR-480098 3430
2 1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
ARV / FCB
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
RECOVERED OIL
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
Item Tags :011-G-0020-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 RECOVERED OIL PUMPS ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480087.pid
Discipline: PRO
SA-JER-DS011-TRJR-480087 2271-011-PID-0021-033
REV:
05
Sheet: 2 of 3
SCALE: NONE Format:
A1
41
41
40
40
FI 0043
39
39
38
38
FT 0043
37
37
INST. PIPING
36
1/2" 35
1/2"
36 35
LV 0060 +
6"x3" MIN.
MIN.
6"-AWS-011033002-106CH2S-N 33 32
34
3" 6"x3"
33
MIN.
34
FC
32
3/4" 6"x4"
31
6"x4" PIPING INST.
30
PIPING
SAMPLE RETURN LINE NOTE 10
2" CL600
3/4"
4"x3"
INST.
2"-AWS-011033025-103CH2S-N
29
31
2" 3"
4"x3"
30
NC
AT 0017
29
NOTE 8
PH
28
28
011-SC-0021
25
6"-AWS-011033001-101CH2S-N
NOTE 9
24
8"x6"
23 22
101CH2S 106CH2S
3/4"-AWS-011033018-106CH2S-N
3/4"
3/4"-AWS-011033024-106CH2S-N UC 0320
D
AC 0017
2"x3/4"
2"-CLD-011033312-101CH2S-N
21 20
LPT
UC
19
3/4" NOTE 3
24
22 21 20
25
LPT
UC
25
23
106CH2S 101CH2S
101CH2S 106CH2S
3/4"
26
MIN.
MIN.
8"x6"
27
3/4"-AWS-011033017-106CH2S-N
250mm MIN.
26
SC
DV
4"-AWS-011033014-106CH2S-N
27
TYPE 23
6969
NOTE 3
19
MIN.
MIN.
17
MIN.
18
MIN.
18
17
16
16
9
PIPING INST. 3/4"
PI 0081
3/4"
3/4"-AWS-011033015-106CH2S-N
3/4"
LPT
4"x2"
2" NOTE 1 6"x3"
3" 3/4"
011-G-0019-A
M
NOTE 7
3/4" 5 4
4"x2"
3/4"
10 9
3/4"
8
011-G-0019-B
M
NOTE 7
3/4" MIN.
2"-OLW-011033311-101CS1P-N 1-1/2"-AWS-011033015-106CH2S-N
11
3"
MIN.
6
2"
12
3/4"-AWS-011033016-106CH2S-N
MIN.
NOTE 1 6"x3"
MIN.
7
MIN.
LPT
PI
13
0082
3/4"
8
PIPING INST. 3/4"
14
6"-AWS-011033002-106CH2S-N
PIPING
10
0249
PI 0251
15
1-1/2"-AWS-011033016-106CH2S-N
CL300
4"-AWS-011033014-106CH2S-N
2"
INST.
TT 0166
PIPING
TI 0166
PI
6"-AWS-011033006-106CH2S-N
11
4"-AWS-011033002-106CH2S-N
12
INST.
13
6"-AWS-011033005-106CH2S-N
14
NOTE 2
1-1/2"-AWS-011033015-106CH2S-N
NOTE 2
15
MIN.
2"-OLW-011033312-101CS1P-N 1-1/2"-AWS-011033016-106CH2S-N NOTE 4
NOTE 4
7 6 5 4
MG 0019 A
MIN.
MG 0019 B
011-G-0019-A/ B VACUUM SYSTEM SOUR WATER PUMPS FROM 011-D-0008
106CH2S 101CH2S
OLW
2"-CLD-011033309-101CH2S-N
SOUR WATER
TO B.L.
TYP. 3
250mm MIN.
TYP. 3
MCC
25
INSULATION: N
OLW
2"-CLD-011033310-101CH2S-N
TO 011-J-0004
2876
DS011-TRJR-480090 3431
DS011-TRJR-480086 3420
GENERAL NOTES
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
m³/h barg bar barg °C kg/m³
011-G-0019-A / B CENTRIFUGAL 55.0 9.30 7.59 54.70 50.00 988.0
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DS011-TRJR-480114 3432
SOUR WATER
25
2874
SIGNAL FROM LC-0060
SOUR WATER
3/4"-OLW-011033307-101CS1P-N
2"-AWS-011033003-106CH2S-N
ZC 0353
106CH2S 101CH2S
2"x1-1/2"
106CH2S 101CS1P
MCC
OLW
250mm MIN.
ZC 0353
1
3/4"-OLW-011033306-101CS1P-N
3/4"
OLW
3/4"
2"x1-1/2"
2
106CH2S 101CS1P
3
MIN.
3
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER NOTES 4 POTABLE WATER 5 DEMI WATER 5,6 DELETED. 1- PROVIDE A STRAIGTH LENGTH OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 6 N.A. 2- CHECK VALVE SHALL BE INSTALLED HORIZONTALLY. 7 N.A. 3- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 8 N.A. 4- DISMONTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION. 9 HP STEAM 7- FOR INSTRUMENT DETAIL, SEE VENDOR DRAWING SA-JER-DS011-DSAZ-480003. 10 MP STEAM 8- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS-TRJR-480275. 11 LP STEAM 9- SAMPLE RETURN CONNECTION TO THE SUCTION PUPM 011-G-0019A/B. 12 HP CONDENSATE 10- LOCATED IN SELF STANDING RACK. 13 MP CONDENSATE 11- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM SA-JER-DS011-TRJR-480272. 14 LP CONDENSATE 15 BFW 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
4131
1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR/ STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
SIGNAL TO 011-AY-0017A/B
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / FCB
RDP / MAC
JAL
DS011-TRJR-480126
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JCP / FCB
RDP / MAC
JAL
PREPARED BY
CHECKED BY
3855
REV
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
2
DS011-TRJR-480086
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM SYSTEM SOUR WATER PUMPS
011-074 011-076 Item Tags :
011-075 011-080
011-G-0019-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480088.pid
Discipline: PRO
SA-JER-DS011-TRJR-480088 2271-011-PID-0021-033
REV:
05
Sheet: 3 of 3
SCALE: NONE Format:
A1
41
41
011-D-0009 VDU OFF GAS SEAL POT
40
40
TRIM: GAS-011034601-101CH4S / AWS-011034601-103CH2S INSULATION: H
39
PI
H
0083
L
39
38
38
37
37
FI 0045
36
PT
36
0083
35
35
FT
34
1"
0045
INST. PIPING
34
1"
33
6"-GAS-011034001-101CH4S-S
32
33
6"-GAS-011034001-101CH4S-S
V
VENT GAS D-0016
NO POCKET
NOTE 4
32 3998
31 RS
31
HPT
2" V
6"
1"-GAS-011034013-101CH4S-N
V1
INST. 1"x3/4"
6"-GAS-011032001-101CH4S-P
MIN.
15000 mm MIN.
27 26 25
MIN.
28
PIPING
MIN.
2008
29
NOTE 4
28
1"-LFL-011034306-101CH2F-N
NC
1" D PI
INST. PIPING 2" 2"
24
NOTE 2
E1 4"
P1
0084
2"
2" L1B
A1
27
MIN.
B1
29
30
29
101CH4S 101CH2F
30
1"
26
V
4"-GAS-011033001-101CH4S-N
PIPING INST.
ZC
ZHSR
0390
0082
25
RESET
24
6"
23
3/4"
22
2" A2
21
2" L2B
B2
5 2148
2" 1/4"
15 14
LI
0062
0062
2"
2" L2A
H
MAG
LG
L
0061
2" L1A
21 20
CLOSED
OPEN
BY-PASS
ZLC
ZLO
ZHA
0082
0082
0082
ZLS 0082 C
ZLS 0082 O
ZHS 0082
19 18
2"
3/4"
INST. NC PIPING
17
D1
011-D-0009
FO TSO
ATM
1/4"
S1
22
2"
2"-OLW-011034301-101CS1P-N
2"-AWS-011034007-101CH2S-N
NOTE 7
16 15
101CH2S 101CS1P
16
LT
PIPING INST.
NOTE 1 14000 mm
2"-AWS-011034004-101CH2S-N NOTE 3
17
UC
+
DE
PIPING INST.
3/4" V 2"-AWS-011034012-101CH2S-P
ZV 0082
S
IA
2"-DWA-011034302-101SR0P-N
2"
19
ZYV 0082 +
20
18
23
D
13
14 13
MIN. LPT
12
11
2"-AWS-011034003-101CH2S-N
NO POCKET
12
3/4"-AWS-011034005-101CH2S-N
MIN.
101CS1P
9
101CH2S
10
11 10 9
8
8
5
250mm MIN.
6
2"-CLD-011034301-101CH2S-N
4
6"-GAS-011034004-101CH4S-S
MIN.
2"-AWS-011034005-101CH2S-N 7
OLW
25
6 5 4
2903
3
3
4"-GAS-011033001-101CH4S-N
6"-GAS-011032001-101CH4S-P
1
2"-AWS-011034003-101CH2S-N
2
SIGNAL TO AIR FUEL
SIGNAL TO AIR FUEL
RATIO CELL A F-0002
RATIO CELL A F-0002
DS011-TRJR-480119
DS011-TRJR-480118
7755
7744
05
13-MAR-2013
AB
04
30-SEP-2011
03
2 1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MSS / STG
AVS / MAC
JAL
OFF GAS
SOUR WATER
VENT GAS
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / FBL
RDP / MAC
JAL
TO 011-D-0008
FROM 011-D-0008
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
IRG / STG
RDP / MAC
JAL
DS011-TRJR-480085 3389
DS011-TRJR-480086 3410
DS011-TRJR-480086 3411
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1- TANGENT LINE OF 011-D-0009 AT LEAST 3M ABOVE UPPER TANGENT LINE OF 011-D-0008. 2- EQUILIBRIUM LINE. 3- OVER FLOW. 4- MAKE CONNECTION ON TOP LINE OR VERTICAL LINE. 5- FV AT 100ºC. 6- DIAMETER: 36" SCH.XS. 7- FOR NOZZLES DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING.
mm mm barg °C barg °C
VENT GAS TO OUTLET 011-C-0007 DS011-TRJR-480094 3433
FROM 011-E-0028
GENERAL NOTES
DRUMS TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
7
011-D-0009 VERTICAL 2500.0 900.0 0.30 50.00 3.50 150.00
NOTE 6 NOTE 5
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
REV
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VDU OFF GAS SEAL POT
011-074 011-076 Item Tags :
011-075 011-080
011-D-0009
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480089.pid
Discipline: PRO
SA-JER-DS011-TRJR-480089 2271-011-PID-0021-034
REV:
05
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
011-D-0016 OFF GAS COMPRESSOR KO DRUM
40
40
TRIM: GAS-011034602-101CH4S / GAS-011034603-103CH4S INSULATION: P
39
39
38
38
6"-GAS-011034002-101CH4S-S
37
VENT GAS TO 011-K-0001
NO POCKET 36
1"
1"
PT
PC 0308
0308
35
PIPING
36
NOTE 13
INST.
PZT 0308
PV 0308
34
PZI 0308
35 34
+
6"-GAS-011034001-101CH4S-S
4"x2"
4"-GAS-011036006-101CH4S-N
ZC 0390
30
ZHSR 0018
+
RESET
NOTE 5 LO FB
3/4" V 6"x3"
PZV 0048
6"-LFL-011034302-101CH2F-N
0.2 %
1"
29
NOTE 4
NOTE 2
3"x2"
2"J3" 3.50 +
V ZC 0390
S
2" V 6"
IA CLOSED ZLC 0018
25 24
V1
OPEN POSITIONER BY-PASS ZLO 0018
ZYC 0018
23
ZLS 0018 C
ZV 0018 +
22
1"
V
ZLS 0018 O
ZY 0018
NOTE 12
1"
ZHS 0018
PIPING
INST.
2" 2"
2" STOP COMPRESSOR
101CH4S 101CS2P
2"-FGS-011034301-101CS2P-S
17
PI
16
3/4"
ZC
LI
LT
0390
0096
0096
INSTR. PIPING
INST.
MIN.
L1B
2" 2"
L3B
1"
2"
MIN.
1" D LG 0098
2" 2"
2" 2"
L3A
24
NOTE 4 29
23 22
2059
21
NOTE 4
1"-LFL-011034301-101CH2F-N 20
NC
19
1"-LFL-011034305-101CH2F-N
18
MAG LT 0097
17
2"
16
1/4"
15
L2A
3/4" V 1/4" 2"-AWS-011034013-101CH2S-P
2" S1
14
L1
2" 2"
2"
14
3/4"
13
B2 D1 2" 2"
7000
21
12
HPT
1/4"
0457 UC
PIPING 2" 2" 2"
L2B
2"
15
6"
NOTE 6
NOTE 1
D
25
4978
1"-GAS-011034012-101CH4S-N
W1
1/4"
HH
101CH4S 101CH2F
29
PIPING
19
26
HPT
A1
2"-GAS-011034015-101CH4S-S
6828
NOTE 4
V
P1
FC TSO
27
NOTE 5
6"
20
29
1"
2"
NOTE 5 FB LC
011-SP-0031
2" 2"
2"
NC
1"-GAS-011034007-101CH4S-S
0.2%
101CH2F 101CH4S
V
FB LO INST.
FB LO NOTE 5
6"x2"
NOTE 8
21
18
B1
PI 0309
ATM
6"-LFL-011034307-101CH2F-N
CL300
011-D-0016
ZHA 0018
3/4" V
101CH4S 101CH2F
DE
28
MIN.
7768
INSTR. PIPING NC
101CH2S 101CS1P
26
29
1"
6"x3"
+
NOTE 2
3"x2"
2" NC
PZV 0055
6"-GAS-011034003-101CH4S-N
MIN.
+
27
RS
ZYV 0018
30
2042
1"
28
32 31
CL300 6"x2"
29
MIN.
+
31
33
FO TSO CL300
2"J3" 3.50
VENT GAS 3998FROM 011-D-0009
2" 4"x2"
MIN.
33 32
37 4001
2"-AWS-011034009-101CH2S-N
13 12
2"-OLW-011034305-101CS1P-N
11
11
LPT
MIN.
10
2"-AWS-011034002-101CH2S-N
9
MIN.
8
3/4"
2"x1-1/2"
011-J-0004
6
LO
2"-AWS-011034001-101CH2S-N
LO
NOTES 10,11 J1 2"x1-1/2" 1-1/2" J2
5
1-1/2"
2"-CLD-011034302-101CH2S-N 2"x1/2"
250mm MIN.
7
3/4"-OLW-011034303-101CS1P-N
MIN.
2"-AWS-011034008-101CH2S-N
9
M1
OLW LC 0097
4 +
3
2"
2"-AWS-011033003-106CH2S-N
2
3/4" D
1
H L
7 6 5 4
25
106CH2S 101CH2S
LV 0097
8
4"-GAS-011036006-101CH4S-N
101CH2S 101CS1P
10
3
2912 VENT GAS
2
FROM 011-D-0017
FO CL600
DS011-TRJR-480093 3438
1
2"-AWS-011034011-101CH2S-N 2" MIN.
3/4"-AWS-011034014-106CH2S-N
MIN.
2"x3/4"
2"-CLD-011034303-101CH2S-N
SOUR WATER
TO 011-D-0008
FROM 011-G-0019
DS011-TRJR-480086 3423
DS011-TRJR-480088 3431
250mm MIN.
106CH2S 101CH2S SOUR WATER
NC
011-J-0004 COMPRESSOR KO DRUM HYDRO-EJECTOR
6800
NOTES
mm mm barg °C barg °C
EJECTORS NUMBER OF STAGES C.W. CONSUMP. Nm³/h STEAM CONSUMP. kg/h IN.OP. PRESS. barg IN. OP. TEMP. °C DES. PRESS. barg DES. TEMP. °C
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MVF / FCB
RDP / MAC
JAL
REV
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
011-D-0016 VERTICAL 2200.0 900.0 NOTE 7 0.30 50.00 3.50 NOTE 3 90.00
13-MAR-2013
25
GENERAL NOTES
DRUMS TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
05
011-J-0004 1 NOTE 9 HOLDS 6, 7 9.30 50.00 15.10 90.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
1- ENSURE THAT NOZZLES FOR LEVEL TRASMITTERS ARE AT THE SAME ELEVATION. 2- MECHANICAL LINK. 3- DES. PRESS. barg AND 3.5 FULL VACUUM AT 100ºC. 4- MAKE CONNECTION ON TOP OF LINE. 5- BLOCK VALVE SHALL BE INSTALLED WITH THE STEM IN OR BELOW THE HORIZONTAL POSITION. 6- FEED DEFLECTOR. 7- DIAMETER: 36" SCH. XS. 8- FOR NOZZLES DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING. 9- MOTIVE FLUID IS 1000 kg/h. 10- LOCKED OPEN DISCHARGE VALVE PROVIDED TO ENSURE THAT EJECTOR IS NOT OVER PRESSURIZED BY MOTIVE FLUID. 11- OPERATING INSTRUCTION REQUIRED TO ENSURE THAT MOTIVE FLUID CANNOT OVER PRESSURIZE THE EJECTOR AND PIPEWORK. 12- REMOVABLE SPOOL PIECE. 13- WHEN THE MOTOR MK-0001 IS NOT RUNNING (011-MXS-K-0001) THE PC-0308 WILL BE SWITCHED AUTOMATICALLY TO MANUAL AND PV-0008 WILL BE OPEN.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 OFF GAS COMPRESSOR KO DRUM
011-074 011-076 011-075 011-080
Item Tags : 011-D-0016
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE
011-J-0004
Electronic Filename SA-JER-DS011-TRJR-480090 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480090 2271-011-PID-0021-034
REV: 05
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
011-S-0006 SUCTION FILTER
40
011-Y-0011 SUCTION SILENCER
011-Y-0012 DISCHARGE SILENCER
SC V
39
41
NOTE 13 TYPE 13 011-SC-0025
40
1" HPT
39
1"-GAS-011035008-101CH4S-P 4"-GAS-011035001-101CH4S-P
4"-GAS-011035001-101CH4S-P 38
VENT GAS TO 011-E-0036
4005
2"H3" 4.00
38
+
1" V
6"-GAS-011034002-101CH4S-S
NO POCKETS
34
8"x6" 8"
TRJR VENDOR
1"
HPT
2"
TP4
2" ANSI CL150 RF N2 PURGE CONNECTION
32
V
D
MIN.
2"-N2L-011035302-101CS1P-N
1"
27
29
4093
6412
UC 0550
30
TI 0550
H
2"
TT 0550
29
NOTE 1
29
28
ZC 0390
27
PI 0550
1"
PT 0550 LL
NC
MIN.
PT 0551 A
PIPING
PDI 0551
PI 0551 B
H
1"
PT 0551 B
INST.
PIPING
26
PI 0551 A L
H
INST.
STOP COMPRESSOR
25
ZC 0390
24
PDI 0552
1" 1"
1" INST.
TRJR
VENDOR
STOP COMPRESSOR
HH
PIPING
PIPING
PI 0553
1"
PIPING
TI 0552
2"H3" 4.00 +
34
PZV 0551
33
3/4" V 6"x3"
+
0.2%
NOTE 8 4"x2"
FB LO NOTE 4
CL300
6"-LFL-011035304-101CH2F-N
29
32
6406
NOTE 1 4"-LFL-011035303-101CH2F-N
1"
31
29 6407
V NOTE 4 FB LC FB LC NOTE 4
NOTE 4 011-SP-0040 NOTE 4
ZC 0390
ZHSR 0028
RESET 29 28
ZYV 0028
ZV 0028
+
+
ZC 0390
30
NOTE 1
101CH2F LO 101CH4S
FO TSO
S
CLOSED
OPEN
BY-PASS
ZLC 0028
ZLO 0028
ZHA 0028
27
IA
26
DE
ZLS 0028 C
H ATM
ZLS 0028 O
25
ZHS 0028
24 23
1"
21
35
INST. 2"
1"
22
2022
NOTE 1
4"-GAS-011035003-101CH4S-P
0552 23
HH
36 29
NOTE 6
INST.
TP-3 4" ANSI CL150 RF 4"-GAS-011035409-101CH4S-P 2" TT
PIPING 1"
PT 0553
0.2 %
6"-LFL-011035301-101CH2F-N
NOTE 4
CL300
FB LO FB LO
2"-GAS-011035406-101CH4S-P
1" 1"
NOTE 1 2"-LFL-011035302-101CH2F-N
NC
TP-5 2" ANSI CL150 RF
1" INST.
2"-LFL-011035309-101CH2F-N
2021
3/4"
TP-14 2" ANSI CL150 RF
2"-GAS-011035408-101CH4S-S
011-S-0006
V HPT
3/4"
LO FB
1"
TP-2 4" ANSI CL150 RF
HPT
2"
31
6"x3"
NOTE 8 4"x2"
2"-GAS-011035405-101CH4S-S
TP-1 8" ANSI CL150 RF GAS INLET
33
+
MIN.
35
3/4" V
PZV 0550
2"-GAS-011034014-101CH4S-S
36 4001 FROM 011-D-0016
101CH4S 101CS1P
VENT GAS
37
HPT
4"-GAS-011035005-101CH4S-P
37
TT 0551
PDT 0552 8"-GAS-011035401-101CH4S-S
4"-GAS-011035404-101CH4S-P
20
8"
TI 0551
VENDOR
HH
TRJR
ZC 0390
22
STOP COMPRESSOR
21 20
4"
19
19
18
18
011-Y-0011
17
011-Y-0012
17
16
8"
FI
8"-GAS-011035402-101CH4S-S 4"
0550 B
4"-GAS-011035403-101CH4S-P
0550 A L
0550 LL
15
5"x4"
15
16
FI
ZC
14
8"
13
14
5"
1"
011-KH-0001
13
12
TUBING
NOTE 15
TUBING
NOTE 15
12
011-K-0001 11
11
GEAR BOX 10
3"
+
MAIN DRIVE MOTOR
SOFT CW
LUBE OIL
LUBE OIL
FROM 011-E-0043
TO 011-D-0028
FROM 011-D-0028
DS011-TRJR-480262 7993
DS011-TRJR-480262 7979
DS011-TRJR-480262 7988
25 6408
TUBING
NOTE 16
2"x1" 1/2" 1/2"
3/4"-PRO-011035404-101SD0P-N 3/4"-PRO-011035423-101SD0P-N
LUBE OIL
LUBE OIL
LUBE OIL
LUBE OIL
TO 011-D-0028
FROM 011-D-0028
FROM 011-D-0028
TO 011-D-0028
DS011-TRJR-480262 7995
DS011-TRJR-480262 7989
DS011-TRJR-480262 7990
DS011-TRJR-480262 7994
FT
FT
0550 B
0550 A 1/2"
1/2"
LUBE OIL TO 011-D-0028
DS011-TRJR-480262 7985
GENERAL NOTES
COOLING WATER
LUBE OIL
TO 011-E-0043
FROM 011-D-0028
DS011-TRJR-480262 7996
DS011-TRJR-480262 7991
2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES SILENCER TYPE FLOW OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP.
Kg/hr barg °C barg °C
COMPRESSORS TYPE THROUGHPUT Nm³/h SUCT. PRESS. barg DISCH. PRESS. barg OP. TEMP. °C in/out DES. PRESS. barg DES. TEMP. °C
011-Y-0011 ABSORTION 1497.0 0.20 50.00 5.00 120.00
011-Y-0012 ABSORTION 1497.0 2.50 122.00 5.00 170.00
011-K-0001 SCREW 750.0 0.20 2.50 50.00 122.00 3.50 150.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
2,3,5,7,9,10,11,12,14 DELETED. 1- CONNECT ON TOP OF PIPE. 4- GATE VALVE SHALL BE INSTALLED WITH THE STEM IN OR BELOW THE HORIZONTAL POSITION AS REQUIRED BY API 520 PART II SECTION 6. 6- MECHANICAL LINK. 8- SUPPLY LOOSE BY COMPRESSOR VENDOR. 13- FOR SAMPLE DETAILS REFER TO: SA-JER-DS011-TRJR-480274. 15- TUBING 1/2" ROTOR COOLING. 16- TUBING 1/2" TIMING GEAR.
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
4 3 TO 011-D-0028
TO 011-D-0028
DS011-TRJR-480262
DS011-TRJR-480262
7986
7987
2 1
06
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
05
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
04
14-JUL-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
RDP / MAC
JAL
00
11-DEC-09
IFD
IFD: ISSUED FOR DESIGN
NPS/STG
RDP/MAC
JAL
DATE
UTILITIES IDENTIFICATION DESCRIPTION
5
FROM 011-D-0028
REV
POS.
6
DS011-TRJR-480262 7992
011-K-0001 VDU OFF GAS COMPRESSOR 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001).
7
LUBE OIL
3/4"-PRO-011035406-101SD0P-N
2"x1"
1"-CWR-011035306-101CS1P-N
PIPING INST.
MIN.
MIN.
250 mm MIN.
3/4"-PRO-011035401-101SD0P-N
3/4"-PRO-011035405-101SD0P-N
1"-CWS-011035307-101CS1P-N
1"
1"-GAS-011035007-101CH4S-P
5
8
3/4"-PRO-011035403-101SD0P-N
1" ANSI CL150 RF
2"-CLD-011035301-101CH2S-P
6
1
9
INST. PIPING
011-KM-0001
2
3/4"
4"-PRO-011035407-101SD0P-N
TP-10
7
3
3/4"
1"
4"x3"
8
4
3"
1" SS TUBING
3/4"
4"x3"
3/4"
3/4" 3/4"
4"-PRO-011035408-101SD0P-N
9
10
RO 0561
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VDU OFF GAS COMPRESSOR
Item Tags : 011-K-0001, 011-S-0006, 011-Y-0011, 011-Y-0012
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480091.pid
Discipline: PRO
SA-JER-DS011-TRJR-480091 2271-011-PID-0021-035
REV:
06
Sheet: 1 of 4
SCALE: NONE Format:
A1
41 40 39 38
41
011-E-0036 OFF GAS COOLER
40
NOTE 3 INSULATON (SHELL / TUBE) : P / N
VENT GAS 4005FROM 011-K-0001
39
4"-GAS-011035001-101CH4S-P
38
37
37
36
36
35
35
34
1"D2" 11.00
34
33
TZV 0007
33
CL300
32
2"x1" 3/4"
31
+
+
2"-CWR-011035304-101CS1P-N
32 31
V FB LO NOTE 5
NOTE 4 MIN.
29 28 27 26 25
4"-CWR-011035302-101CS1P-N
3
30 29
TI 0209
28 27
CL300
MIN. 3/4" D
4700
24
2"-CWR-011035303-101CS1P-N
30
26
011-E-0036
2" 4"
4"
25
VENT GAS TO 011-D-0017
4"-GAS-011035002-101CH4S-N
CL300
24 4009
23
23
4" 22
22
21
21
20
20
4"
19
19
18
3 4701
17
4"
4"-CWS-011035302-101CS1P-N MIN. 3/4" D
CL300
18
4" 17
16
16
15
15
TI
14
0210
H L
TI
NOTE 6 14
0210 L
13
13
TT
12
12
0210 11
11
CL300 2"
10
10
9
9
8
8
7
7
6
6
5
5
4
4
3
3
2
2
1
1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MVF / FBL
RDP / MAC
JAL
REV
GENERAL NOTES
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-E-0036 MULTI-HAIR PIN 2.50 6.00 122.00 36.50 41.50 46.50 8.50 11.00 150.00 80.00 52.7 0.11
NOTE 7
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER 4 POTABLE WATER NOTES 5 DEMI WATER 1,2 DELETED. 6 N.A. 3- MULTITUBES TYPE. 7 N.A. 4- AT GRADE. AT SAFE LOCATION. 8 N.A. 5- THE GATE VALVE SHALL BE INSTALLED WITH STEM IN OR BELOW THE HORIZONTAL POSITION. 9 HP STEAM 6- LOCATE NEAR 011-E-0036 CW BUTTERFLY VALVES. 7- FULL VACUUM AT 150 ºC ON SHELL SIDE. 10 MP STEAM 11 LP STEAM 12 HP CONDENSATE 13 MP CONDENSATE 14 LP CONDENSATE 15 BFW 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A.
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080
011-E-0036
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VDU OFF GAS COOLER ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480092.pid
Discipline: PRO
SA-JER-DS011-TRJR-480092 2271-011-PID-0021-035
REV:
05
Sheet: 2 of 4
SCALE: NONE Format:
A1
41
41
011-D-0017 AMINE ABSORBER KO DRUM
40
40
TRIM: GAS-011036601-101CH4S TRIM: GAS-011036602-103CH4S
39
39
38
38
37
37
36
36
4"-GAS-011036006-101CH4S-N 35
35
34
34
4"-GAS-011036001-101CH4S-N
33
33
RS NOTE 6
32
32
2" V
31
2" V1
30
31
2046
HPT
4"
1"-LFL-011036307-101CH2F-N
B1
29
1"
NOTE 2 101CH2F 101CH4S
29
30
D
NC
ZC 0390
1"-GAS-011036008-101CH4S-N
28
MIN.
011-D-0017
27
1" MIN.
NOTE 3
ZV 0027
6" W1
25 24
1" P1
2" 2"
2"
PI
2"
22
1/4" LC 0070
21
LT 0070
2" 2"
L1B
L3B
L2B
2"
2"
1"
2" 2"
V
2" 2"
2"
2"
L3A
L2A
MIN.
2"
2"
2"
2"
OPEN
BY-PASS
ZLC 0027
ZLO 0027
ZHA 0027
27 26
IA
25
ZLS 0027 C
ZLS 0027 O
ZHS 0027
24 23 22
LT 0072
LI 0072
H L
MAG LG 0071
21
DV
20
1/4"
L1A
S
CLOSED
ATM
2" 2"
UC
19 18
2"-AWS-011036009-101CH4S-P
14,000
18
2"
28
DE
PIPING. INSTR.
INST.
1/4"
1/4" 19
2" 2"
INST. PIPING
20
1"x3/4"
PIPING
A1
23
S
0118
4"
VENT GAS 4"-GAS-011035002-101CH4S-N 4009FROM 011-E-0036
FC TSO
ZYV 0027 +
+
26
ZHSR 0027
29
RESET
B2
17
1"
2" 16
INST. NC PIPING
4"-GAS-011036001-101CH4S-N NO POCKETS
VENT GAS TO 011-C-0007
4013
17 16
2" D1 2"-AWS-011036006-101CH4S-N
15
15
101CH4S 101CS1P
14
14
2"-OLW-011036302-101CS1P-N 13
12
12
4"-GAS-011036006-101CH4S-N
13
OLW 11
MIN.
10
LV 0070 +
LPT
2"
2"-AWS-011036002-101CH4S-N
MIN.
9
FC CL300 NOTE 4
8
11 10 9 8
1"-AWS-011036007-101CH4S-N
7
7
1"
MIN.
6
1"
6
MIN. 1"
2"-AWS-011036007-101CH4S-N
+
1"-AWS-011036004-101CH2S-N DV
1
NC
2"-CLD-011036301-101CH2S-N
011-SC-0045 DV SC TYPE 23 NOTE 5
TO 011-D-0016
OLW
1
1"
1"-AWS-011036005-101CH4S-N
D 2"x1"
2908
101CH4S 101CH2S
2"-CLD-011036302-101CH2S-N SOUR WATER
250mm MIN.
1"-AWS-011036003-101CH4S-N
TO 011-D-0008
2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1- DESIGN PRESSURE: PRESSURE: 4.0 barg AND HALF VACUUM (HV) AT 150ºC. 2- MAKE CONNECTION ON TOP OF LINE. 3- FOR NOZZLES DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING. 4- FLASHING SERVICE. 5- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS011-TRJR-480275. 6- REMOVABLE SPOOL PIECE
mm mm barg °C barg °C
NOTE 1
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS/ MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS/ MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / STG
AVS/ MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / FCB
RDP/ MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JCP / FCB
RDP / MAC
JAL
REV
4986
GENERAL NOTES
011-D-0017 VERTICAL 2000.0 900.0 2.10 41.00 4.00 105.00
05
25
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001).
DRUM TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
2
DS011-TRJR-480090 3438
25
MIN.
2"-AWS-011036001-101CH2S-N
DS011-TRJR-480086 3405
3
VENT GAS
2"x1"
MIN.
2"x1"
2
4
101CH4S 101CH2S
1"
250mm MIN.
101CH4S 101CH2S
3
5
1"-OLW-011036301-101CS1P-N
101CH4S 101CS1P
RO 0068
4
MIN.
5
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
DESCRIPTION
19 N.A. 20 FUEL OIL 21 FUEL GAS 22 N.A. 23 N.A. 24 N.A. 25 CLOSED DRAIN 26 N.A. 27 L.P. NITROGEN 28 H.P. FLARE 29 L.P. FLARE 30 SOUR/ACID FLARE 31 PILOT GAS 32 AUX COOLING WATER FLO FLUSHING OIL AMD AMINE CLOSED DRAIN CND TURBINE CONDENSATE
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VDU OFF GAS AMINE ABSORBER
011-074 011-076 Item Tags :
011-075 011-080 011-077 011-079 011-071
011-D-0017
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480093.pid
Discipline: PRO
SA-JER-DS011-TRJR-480093 2271-011-PID-0021-036
REV:
05
Sheet: 1 of 3
SCALE: NONE Format:
A1
011-C-0007 AMINE ABSORBER
4"x3"
PZV 0034
011-SP-0032
PT
PT
PC
CL300
0068
0112
0113
0113
4"x1-1/2"
3/4" V
33
PZV 0033
4"x3" FB LO NOTE 4
2"
4"x1-1/2"
1"
101CH2F 101CH4S NC 1"
29
ZC 0368
28
FC 0067 A
FB LC
V
2"
FMC
NOTE 3
NOTE 4
2" CL300
INST. PIPING
P3
25
1/2"
2" 24
PIPING INST.
21
+
4"x3"
1-1/2" 3"x1-1/2"
3"x1-1/2"
FC UC UC
1/2" 1/2"
3/4"
3/4" FT
3"x1-1/2"
0067 B
ID 20"
3"-AMI-011036006-101CH4S-H
MIN.
3/4" D
250mm MIN.
17
2"-AMD-011036306-101CH2S-P
15
2"-AMI-011036002-103CS2D-P START UP LINE
4660
STOP PUMP
12
HH
ZC
LI
LT
0358
0075
0075
2" 1/4" 2" 2" 2"
LL
011-SC-0044
4" A2 L3B
L2B 2"
1/4"
2" 2"
H
PDI 0115
ID 20"
M1
PT
1"
23 22 21 20
29
3"-AMI-011036003-103CH2S-P
2011
NOTE 2
ZC 0334
LG
1/4"
INST. PIPING
ZHXS 0112
H
7745
L
ES ZC 0317
ES
ZYV 0112
S
NOTE 5
ZHSR 0112
NC
ATM ZV 0112
MIN.
TI 0214
ZC 0358 OPEN BY-PASS
CLOSED ZLC 0112
ZHA
ZLO 0112
0112
ZLS
ZLS
ZHS
0112 C
0112 O
0112
TT 0214
2" CL300 4"x3"
3"-AMI-011036005-101CH4S-P
101CH4S 101CS1P
4"x3"
FC TSO
OLW
ZLC
ZLO
ZYC
ZHA
0030
0030
0030
0030
ZLS 0030 C
ZLS 0030 O
ZY 0030
ZHS 0030
16 15
+
IA
14 13
ATM
12
6"x4" 9 8 7 6 5 4
VENT GAS
VENT GAS
VENT GAS
FROM 011-D-0009
TO 011-F-0002
TO 011-F-0002
DS011-TRJR-480089 3433
DS011-TRJR-480118 3452
DS011-TRJR-480119 3456
OLW
FROM B.L.
AMD
05
13-MAR-2013
AB
2 1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DIC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MSS / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
VJS / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
4668
NOTES
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
OPEN POSITIONER BY-PASS
CLOSED
MIN. 101CH4S 101CH2S
DS011-TRJR-480137 3443
15400.0 910.0 2.00 71.00 4.20 100.00
17
10
250mm MIN.
3"-OLW-011036307-101CS1P-N
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
mm mm barg °C barg °C
18
ZC 0336
3
3/4"-OLW-011036308-101CS1P-N
LEAN AMINE
011-C-0007
19 4023
11
RESET
+
IA
GENERAL NOTES
COLUMN TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
ZC 0336
RICH AMINE TO 011-G-0023-A/B
6"x4"
1"x3/4"
1"
101CH4S 101CS1P
3"-AML-011099001-103CS2D-H 7765
RESET
DE
NOTE 9
DE
MIN.
ZHSR 0030 ZYV 0030
S
ZV 0030
ZHXS 0112 L
2"-AMI-011036009-101CH4S-P
ZC 0336
V
0074
3"
HIXS 0041 A
ZC 0390
0074 MAG
27
24
LC
2"-AMD-011036302-101CH2S-P SIGNAL TO AIR FUEL RATIO CONTROL CELL A F-0002 DS011-TRJR-480118
4020
HPT
1"-AMI-011036009-101CH4S-P
SIGNAL TO AIR FUEL RATIO CONTROL CELL B F-0002 DS011-TRJR-480119
28
25
2 1
30
26
101CH4S 103CH2S
3
NOTE 2
DV 1"-GAS-011036013-101CH4S-S TYPE 4 NOTE 8
LT
MIN.
3"-AMI-011036022-101CH4S-P
31
011-SC-0030
FC TSO
B3
D
29 2018
+
PIPING INST.
NOTE 1
4"-LFL-011036304-101CH2F-N
TO LV-0074
+
4
D
2"
3"
32
FO 4"-GAS-011036003-101CH4S-S TSO
PIPING INST.
L1A
2"
33
NOTE 2
6 5
ZHS 0029
6"x4"
1"
2" 2" S
ZLS 0029 O
4"x2"
2"
1"-LFL-011036306-101CH2F-N
L2A
2"
2"-AMI-011036023-101CH4S-P
35
29
NC
6000mm
7
1"
NC
0073 UC
ZHA 0029
NC
1"x3/4"
0115 A
1/4"
ZLO 0029
1"-LFL-011036303-101CH2F-N
2" 2"
2" 2"
L3A
1" D
8
L1B
SC TYPE 31 NOTE 8
9
P4A
P1
NO POCKET
13
1
2" 2"
ZLC 0029
SIGNAL
4"x2"
101CH4S 101CH2F
10
PI 0119
36
29
INST. PIPING
ZC 0368
AMD
1"
PT 0115 B
BY-PASS
ZLS 0029 C
ZV 0029
V
1"
6"x4"
FO CL300
3/4" D 101CH2S 101CH4S
OPEN
2010
11 ID 20"
1"
2" 4"x2"
HPT
2"
M2
3/4"-AMI-011036012-103CS2D-H
INST.
1"
1"
D
A3
20
103CS2D 101CH2S
10
2" 2"
CLOSED
1"-GAS-011036011-101CH4S-S
2"
2"x3/4"
11
PI 0117
1-1/2" 3"x1-1/2"
FI 0067 B L
VENT GAS 4"-GAS-011036001-101CH4S-N 4013 FROM 011-D-0017
M3
B1 2" 2" 2" P2
INST. PIPING
+
1" ID 20"
PT 0456
1"
4"x2"
011-C-0007
P4B
3/4"-AMI-011036007-103CS2D-P
16
4" W A1 3"
3/4"
NC
19
PV 0113 +
PIPING
20
18
1"
2"-AMI-011036001-101CH2S-H
FV 0067
1/2"
23 22
1"
37
ATM
34
SC
INST. PIPING
MIN.
4"x3"
1/2"
NOTE 6
MIN.
L
FT 0067 A
103CS2D 101CH4S
26
TT 0217
MIN.
H
TI 0217
1/2"
V
M4 27
1"
2" V
4" B2
2"
4"
1"
CL300 4"
2"
1/2"
4"-GAS-011036003-101CH4S-S
PI 0116 NOTE 4 FB LO
1/2"
1"-AMI-011036301-101CH4S-P
30
V
V
PI 0456
PT 0114
INST. PIPING
MIN.
31
CL300
TT 0213
1600 mm 101CH2S 103CS2D
32
+
1"
MIN.
+
1"-GAS-011036012-101CH4S-S
4"-GAS-011036007-101CH4S-P
1-1/2"H3" 3.50
34
14
FT
+
38
DE
HH
101CH4S 101CH2F
NOTE 7
2015
35
4"-LFL-011036301-101CH2F-N
TI 0213
H
PI 0114
MIN.
29
L
+
3/4" V
39
IA
101CH4S 101CH2F
0.2 %
36
NOTE 4 LO FB
1-1/2"H3" 3.50
0112
40
S
+
H
PI
41
RESET
ZHSR 0029
4"-GAS-011036005-101CH4S-S
37
FI 0068
ZC 0336
ZYV 0029
0336
DS011-TRJR-480273 10784
38
ZC 0334
ZC
4"-GAS-011036004-101CH4S-S
1"x3/4"
1"-LFL-011200310-101CH2F-N
FROM SC-0030
MIN.
39
6"-GAS-011034004-101CH4S-S
LFL
ZC 0390
OPEN ZV-0029
INSULATION: H TRIM: AMI-011036601-103CH2S / GAS-011036603-101CH4S / GAS-011036604-103CH4S
40
3"-AMI-011036003-103CH2S-P
41
1- CONNECTION FOR ANTI-FOAM INJECTION. 2- CONNECTION ON TOP OF FLARE SUBHEADER LINE. 3- MECHANICAL LINK. 4- GATE VALVE SHALL BE INSTALLED WITH STEM IN OR BELOW THE HORIZONTAL POSITION. 5- LOCAL EMERGENCY SWITH BEHIND OR IN SAFE LOCATION. 6- FOR NOZZLES DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING. 7- MAKE CONNECTION ON TOP OF LINE. 8- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS011-TRJR-480273 (SC-0030) AND SA-JER-DS011-TRJR-480275 (SC-0044) 9- OPEN ONLY IF LIGHT-OF BURNERS (FG).
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
DESCRIPTION
19 N.A. 20 FUEL OIL 21 FUEL GAS 22 N.A. 23 N.A. 24 N.A. 25 CLOSED DRAIN 26 N.A. 27 L.P. NITROGEN 28 H.P. FLARE 29 L.P. FLARE 30 SOUR/ACID FLARE 31 PILOT GAS 32 AUX COOLING WATER AMD AMINE CLOSED DRAIN
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080 011-079
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VDU OFF GAS AMINE ABSORBER
Item Tags : 011-C-0007
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480094.pid
Discipline: PRO
SA-JER-DS011-TRJR-480094 2271-011-PID-0021-036
REV:
05
Sheet: 2 of 3
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
37
36
36
35
35
34
34
33
33
32
32
31
SIGNAL
31
4020FROM LG-0074
FI 0154
30
30
29
29
28
28
FT 0154
27 26
LV 0074 +
3"-AMI-011036015-103CH2S-P
20 19 4023
RICH AMINE FROM 011-C-0007
3"-AMI-011036003-103CH2S-P
18 17
25
MIN.
3/4"
1/2"
24
FC
3/4"
3"x1-1/2" 1-1/2" 3"x1-1/2" NC DV
23
3/4"-AMI-011036021-103CH2S-P
22 21
UC
3/4"-AMI-011036020-103CH2S-P
23
1/2"
26
1-1/2" 3"x1-1/2"
3"x1-1/2"
3"-AMI-011036004-103CH2S-P
24
1/2"
MIN.
25
1/2"
27
INST. PIPING
22 21 20 19
TYPE 24
SC 011-SC-0031
18
NOTE 5
3/4"-AMI-011036018-103CH2S-P 17
MIN. 16
16
D
15
2"x3/4"
MIN.
3/4"
15
UC
UC MIN.
7 6
NOTE 2
0133 INST. PIPING
3/4"
3/4"
3/4"
3/4" LPT
5 4
1-1/2"
PIPING INST. 3/4" 3/4"
011-G-0023-A
NOTE 1
3"x1-1/2" 1-1/2" 1/2"
/2" 1"x1
1"
0120
3"x1" 3/4"
1/2" . N MI
PI
0134
PDT
NOTE 2
0134 INST. PIPING
3/4"
3/4"
3/4"
3/4" LPT
3/4 "
M
011-G-0023-B NOTE 1
3/4"-AMI-011036016-103CH2S-P
1-1/2"
3
PIPING INST. 3/4" 3/4"
3"x1-1/2"
1-1/2"
1/2" /2" 1"x1
1/2" . N MI
3/4 "
M
11 AMD
10
4676
9
PI
3/4"-AMI-011036017-103CH2S-P 3/4"
MIN. 2"-OLW-011036309-101CS1P-N
2"-OLW-011036310-101CS1P-P
NOTE 4
NOTE 4
TYP. 3 2"-AMD-011036303-101CH2S-P MG 0023 A
0358
MCC TYP. 3
OLW
2"-AMD-011036304-101CH2S-P
AMD
011-G-0023-A / B RICH AMINE PUMPS
4672
INSULATION: P
OLW
AMD 4675
NOTES 1- PROVIDE A STRAIGHT LENGHT OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 2- CHECK VALVE SHALL BE INSTALLED HORIZONTALLY. 3- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 4- DISMOUNTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
6 5 4
5- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS011-TRJR-480275. 6- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM SA-JER-DS011-TRJR-480272
05
13-MAR-2013
AB
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
RICH AMINE TO B.L.
DS011-TRJR-480233 3465
DS011-TRJR-480137 3469
2 1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
ARV / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS.
AMINE FROM 011-G-0027
3/4"-OLW-011036304-101CS1P-N
MG 0023 B
4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
m³/h barg bar barg °C kg/m³
101CS1P
0317
103CH2S
ZC
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE DRAIN WITH UTILITY CONNECTIONS.
011-G-0023-A / B CENTRIFUGAL 9.6 8.70 5.29 13.00 71.00 1045.0
103CH2S 101CH2S
OLW ZC
GENERAL NOTES
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
2"x1-1/2"
MIN.
103CH2S 101CH2S
3/4"-OLW-011036303-101CS1P-N
250mm MIN.
MCC
101CS1P
0358
103CH2S
0317
250mm MIN.
OLW ZC
MIN.
1
ZC
7
3
1-1/2"-AMI-011036017-103CH2S-P
2"x1-1/2"
8
MIN.
1-1/2"-AMI-011036016-103CH2S-P 2
12
0121
3"x1"
1"
13
2"-AMD-011079003-103CH2S-P
8
PDT
2"-AMD-011036305-101CH2S-P
H
MIN.
9
0133
MIN.
3"-AMI-011036011-103CH2S-P
10
PDI 3"-AMI-011036014-103CH2S-P
PDI 11
MIN.
H 1-1/2"-AMI-011036016-103CH2S-P
12
NOTE 3
3/4"
3"-AMI-011036004-103CH2S-P
LPT
NOTE 3
1-1/2"-AMI-011036017-103CH2S-P
3/4"
103CH2S 101CH2S
250mm MIN.
LPT
13
MIN.
14
MIN.
14
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION
N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER AMD AMINE CLOSED DRAIN
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 RICH AMINE PUMPS
011-074 011-076 Item Tags :
011-075 011-080 011-079
ORIGINAL SIGNED IN PROJECT FILE
011-G-0023-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480095 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480095 2271-011-PID-0021-036
REV: 05
Sheet: 3 of 3
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
37
36
36
35
35
34
34
33
33
32
32
31
31
30
30
29
29
10"-DIE-011037003-103CS1P-H 28
28
27
27
26
26
25
25
24
24
18"-DIE-011030001-101CS1P-H
18"-DIE-011030001-101CS1P-H 101CS1P 103CS1P
MIN.
20 19
LPT
LPT NOTE 4
2"
18
UC
0046
19
UC
1/2"
MIN.
FV 0046
1/2"
+
4" 6"x4"
NOTE 2
3/4"
NC
MIN.
6"x4" 3/4"
20
FT
17 16
21
FC 0046
NOTE 4
2"
MIN.
22
18
103CS1P 101CS1P
21
MIN.
101CS1P 103CS1P
17
MIN.
22
23
6"-DIE-011037010-103CS1P-H
23
FC
16
NOTE 2
3/4"
PI 0085
10"
CL600
MIN.
CL600 CL600
MIN
6
3/4"
M
2"
1/2"-DIE-011037011-103CS1P-P 3/4"
011-G-0015-B
CL600 NOTE 1
10" 18"x12"
3/4"
M
2"
PIPING INST.
3/4" 25 4988
MCC TYP. 3 MG 0015 A
103CS1P 101CH2S
3/4"-OLW-011037301-101CS1P-N
ZC
ZC
0312
0355
TYP. 3 103CS1P 101CH2S
LVGO REFLUX
2"-CLD-011037302-101CH2S-P
3/4"-OLW-011037302-101CS1P-N
25
25
2873
2872
INSULATION: N
LVGO DS011-TRJR-480080 3314
GENERAL NOTES
m³/h barg bar barg °C kg/m³
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
4
LVGO PA
2
TO 011-C-0003
TO 011-E-0005
DS011-TRJR-480080 3313
DS011-TRJR-480006 2850
1
OLW
FROM 011-C-0003
011-G-0015-A / B CENTRIFUGAL 765.0 13.30 9.49 21.00 141.00 801.0
5
2"-CLD-011037301-101CH2S-P
011-G-0015-A / B LVGO PUMPS
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
6
3
MCC
MG 0015 B OLW
7
NOTE 3
103CS1P 101CS1P
0355
NOTE 3
8
MIN.
MIN.
0312
2"-DIE-011037012-103CS1P-P
103CS1P 101CS1P
1
ZC
MIN.
18"-DIE-011030001-101CS1P-H
2
ZC
250mm MIN.
3
MIN.
1/2"-DIE-011037012-103CS1P-P 3/4"
MIN.
103CS1P 101CS1P
2"-CLD-011037303-101CH2S-P
250mm MIN.
2"-DIE-011037011-103CS1P-P
9
0086
5 4
10
PIPING 103CS1P 101CH2S
CL600
MIN
11
D
2"x3/4"
PI
NOTE 6
12
3/4"
CL600
3/4"
3/4"
2"-DIE-011037012-103CS1P-P
10"-DIE-011037009-103CS1P-H 3/4"
3/4"
13
MIN.
INST
LPT
PIPING INST.
18"x12"
3/4"-DIE-011037013-103CS1P-P
14
10"-DIE-011037003-103CS1P-H
NOTE 6 LPT NOTE 1
7
011-G-0015-A
NC
6"x3"
6"-DIE-011037004-101CS1P-H
8
3/4"
3/4"
3"
6"x3"
250mm MIN.
PIPING
9
PIPING
INST
PI 0235
MIN.
10
PI 0234
INST.
11
PIPING
12
2"-DIE-011037011-103CS1P-P
13
INST.
18"-DIE-011037001-103CS1P-N
14
18"-DIE-011037002-103CS1P-H
15
10"-DIE-011037003-103CS1P-H
15
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 1 FIRE WATER 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 2 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER 4 POTABLE WATER NOTES 5 DEMI WATER 6 N.A. 5 DELETED. 1- PROVIDE A STRAIGHT LENGHT OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 7 N.A. 2- CHECK VALVE SHALL BE INSTALLED HORIZONTALLY. 8 N.A. 3- DISMOUNTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION. 9 HP STEAM 4- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 10 MP STEAM 6- FOR FURTHER INFORMATION SEE PUPS AUXILIARY DETAILS DIAGRAM: SA-JER-DS011-TRJR-480253. 11 LP STEAM 12 HP CONDENSATE 13 MP CONDENSATE 14 LP CONDENSATE 15 BFW 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
00
11-DEC-09
IFD
IFD: ISSUED FOR DESIGN
ARV / JLM
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080 011-077
011-G-0015-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 LVGO PUMPS ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480096 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480096 2271-011-PID-0021-037
REV: 05
Sheet: 1 of 3
SCALE: NONE Format:
A1
41
HPT
011-A-0005-A/B / C/D / E/F / G/H LVGO PUMPAROUND COOLER
40
41
2"-LFL-011037302-101CH2F-N
29
40
4989
NOTE 6
NOTE 2
39
39
101CH2F 103CS1P
38
38
NC 37
MIN. 36
2"-DIE-011037021-103CS1P-P
MIN.
37
3/4"
36
D 35
34
34
MIN.
35
33
33
10"-DIE-011003001-103CS1P-P HPT
32
MIN. 10"x8"
8"-DIE-011003001-103CS1P-P
32
10"x8"
NOTE 7
31
31
MIN. 6"
6"
6"
6"
30 29
1%
6"
1%
29
6"
1%
6"
1%
6"
30
28
28
27
011-A-0005-A/B
6"
26
NOTE 5 1%
N1 25
N4
N2
6"
24 23
N4
6"
011-A-0005-C/D
6"
N1
N1
N2
N2
VSDS 6"
22
1-1/2" D
6" N1
N1
N2
N2
M
M
6"
6"
1%
N4
N4
6"
6"
D 1-1/2"
011-A-0005-E/F
6"
VSDS
NOTE 6
21
N4
N4
6"
6"
1-1/2" D D 1-1/2"
NOTE 5 1%
6"
011-A-0005-G/H
6"
N1
N1
N2
N2
VSDS
M
6"
M
6"
NOTE 6
6"
26
N1 N4
6"
6"
1-1/2" D1-1/2" D
27
NOTE 5 1%
N4
25
N2 6"
1-1/2" D1-1/2"
24 23
VSDS
M
6"
M
6"
NOTE 6
M
6"
M
22
NOTE 6
21 20
20 19
MCC 18
ZC 0413
MCC
TYP.8
17
TYP.7
16
0005 A NOTE 4
14
NOTE 4
MCC
TYP.8
MA 0005 B
MA
15
MCC
ZC 0413
MCC
TYP.7
MCC
TYP.8
TC 0369 A
0005 C
NOTE 4
NOTE 4
MCC 18
TYP.8
TYP.7
MA
0005 D
MA
19
ZC 0413
MCC
TYP.7
MA 0005 E
TC 0369 C 10"x8"
16
0005 H
MA 0005 G
TC 0369 E
NOTE 4
NOTE 4 10"x8"
NOTE 4
TC
8"-DIE-011037005-103CS1P-P
13
MIN.
9 8 7
TT 0168
TI 0168
9 8
10"x4"
10"-DIE-011037005-103CS1P-P
103CS1P 101CS1P
MIN. TY 0369
4027
TT 0369
5 4
2"
3
103CS1P 101CH2S
2
10"-DIE-011037008-103CS1P-P
1
3/4"-OLW-011037303-101CS1P-N
250mm MIN.
10"-DIE-011003001-103CS1P-P
2
OLW
2"-CLD-011037308-101CH2S-P
1
25 2815
LVGO PA FROM 011-E-0005
LVGO PA TO 011-C-0003
DS011-TRJR-480006 2849
DS011-TRJR-480080 3316
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
ARV / FCB
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 3 DELETED. 1- OP. TEMP. IN / OUT ºC: 126 / 60. 2- MAKE CONNECTION ON TOP OF LINE. 4- VIBRATION TRIP IS REQUIRED FOR EACH MOTOR AS PER MOTOR TYPICAL. 5- 1% SLOPE IN LAST PASS OF TUBE BUNDLES. 6- AIR COOLER HAS 4 BAYS WITH 2 MOTORS / FANS EACH AND 2 BUNDLES PER BAY. 7- PIPING ARRANGEMENT TO BE SYMETRICAL.
m² barg °C barg °C Gcal/h
011-A-0005-A/B - G/H FORCED 2151.0 10.80 126.00 NOTE 1 21.00 190.00 16.25
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
7 6
MIN.
3
AIRFINS TYPE SURFACE OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP DUTY
LIGHT VACUUM GASOIL TO 011-E-0029
4"-DIE-011037005-103CS1P-P
10ø MIN.
2"x1-1/2"
4
10
H
2"
6 5
12 11
1-1/2"-DIE-011037023-103CS1P-N
10
14
0369 G
12 11
15
NOTE 4
NOTE 7
MIN.
17
MA
0005 F
MA
8"-DIE-011037005-103CS1P-P
13
ZC 0413
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 LVGO PA- COOLER
011-074 011-076 011-075 011-080
Item Tags :
011-A-0005 A/B-G/H
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480097.pid
Discipline: PRO
SA-JER-DS011-TRJR-480097 2271-011-PID-0021-037
REV:
05
Sheet: 2 of 3
SCALE: NONE Format:
A1
41
41
011-E-0029 LVGO COOLER
40
40
INSULATION (SHELL / TUBE) :P / N 39
39
38
38
37
37
36
36
4"-DIE-011037005-103CS1P-P 35
35
34
34
1"D2" 16.20 +
+
0330
TZV 0004
PZV 0069 B
+
CL300
2"-CWR-011037302-101CS1P-N 3/4" V
MIN.
NOTE 2
27
FB LO
4"x1-1/2"
NOTE 3
31
PZV 0069 A +
B2
4" 4" 6"x4"
3/4"
TI
D
MIN.
H
FB LO
18 17
4"-CWS-011037301-101CS1P-N
27
FC AI 3/4"
NC
103CS1P
25
0012 A 24
V NOTE 6 CLOUD POINT
FT 0144
011-SP-0033 NOTE 3
FB LC
2"
NOTE 3
INST. PIPING
1/2"
1/2"
INST. PIPING
AT 0012
22
2"
FV 0144
2"
3" 6"x3"
6"x3"
MIN.
6"-DIE-011037007-103CS1P-N
FC
3
3
4709
4710
3"
4"x3"
15
SC NOTE 7 TYPE 5 MIN.
250mm MIN.
11
103CS1P 101CH2S
250mm MIN.
4"-DIE-011037005-103CS1P-P
12
2"-CLD-011037309-101CH2S-P
2"
TT 0039
TI 0039
H
10 9
2"-CLD-011037004-101CH2S-P 25
8
25
2547
4991
LIGHT VACUUM GASOIL 4027FROM 011-A-0005-A/D
6"-DIE-011037007-103CS1P-N
7
13
3/4"-DIE-011037017-103CS1P-N 2"x3/4"
103CS1P 101CH2S
14
3/4"-DIE-011037015-103CS1P-N 3/4"
MIN.
2"x3/4"
8
16
NC 011-SC-0002
3/4"-DIE-011037014-103CS1P-N
9
19 18
4"x3"
3/4"
10
20
17
MIN.
11
21
3/4"
14
12
PIPING. INST.
+
3/4"-DIE-011037020-103CS1P-N
13
23
RETURN SAMPLE LINE
LPT 2"
16 15
26
0144
101CH2F
MIN.
19
4"-CWR-011072306-301FE0W-N
20
28
FB NOTE 3 LO
4"x1-1/2"
NOTE 8
TT 0349
V
3/4"
22
AG 101CS1P UG 301FE0W
29
3/4" 4"x3"
0349
MIN.
D
3/4"
30
V
A2
A1
NOTE 9
NOTE10
+
4"
B1
2"-CWR-011037301-101CS1P-N
23
011-E-0029
4"
25 24
1-1/2"G3" 18.24
3/4"
26
21
29
2"-PRO-011033026-103CS1P-N
28
4"-LFL-011037301-101CH2F-N
10ø MIN.
29
32
0.2%
MIN.
2"x1"
NOTE 3 LO FB
2139
4"-CWR-011037301-101CS1P-N
30
2" CL300
V
MIN.
2"-CWR-011037303-101CS1P-N
31
3/4" 4"x3"
+
MIN.
32
33
4"-DIE-011037016-103CS1P-N
33
1-1/2"G3" NOTE10 18.24
TI
6 5 4
7 6 5 4
3
3 RECOVERED OIL
LVGO
FROM 011-G-0020
TO HP HDS
DS011-TRJR-480087 3430
DS011-TRJR-480132 3474
2
6"-DIE-011037006-103CS1P-N
1
SIGNAL TO B.L.
DS011-TRJR-480135 6967
GENERAL NOTES
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-E-0029 AES 9.00 6.00 60.00 36.50 50.00 46.50 21.00 16.20 126.00 80.00 56.5 0.21
NOTE 8
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER NOTES 4 POTABLE WATER 1,4,5 DELETED. 5 DEMI WATER 2- AT GRADE. AT SAFE LOCATION. 6 N.A. 3- GATE VALVE SHALL BE INSTALLED WITH STEM IN OR BELOW THE HORIZONTAL POSITION. 6- LOCATED IN ANALYZER SHELTER 011-AS-0001. SEE PID SA-JER-DS011-TRJR-480289. 7 N.A. 7- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS11-TRJR-480274. 8 N.A. 8- H.V.@ 150ºC. SHELL SIDE. 9 HP STEAM 8- MECHANICAL LINK. 10 MP STEAM 9- MAKE CONNECTION ON TOP OF LINE. 11 LP STEAM 10- SET PRESSURE READJUSTED BASED ON THE DISTANCE FROM UPPER TL OF E-0029 TO PZV. ELEVATION DIFFERENCE SHOULD NOT BE HIGHER THAN 15,1 M. 11- DELETED. 12 HP CONDENSATE 13 MP CONDENSATE 14 LP CONDENSATE 15 BFW 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A.
05
13-MAR-2013
AB
04
30-SEP-2011
03
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO AMD CND
N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL AMINE CLOSED DRAIN TURBINE CONDENSATE
4030
1
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
LVGO
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / FCB
RDP / MAC
JAL
TO SLOP
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
IRG / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
DS011-TRJR-480138 3472
DESCRIPTION
2
DS011-TRJR-480080
AB: AS BUILT
UTILITIES IDENTIFICATION REF. DWG POS.
SIGNAL FROM LC-0044
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 LVGO - COOLER
Project:
011-074 011-076 011-075 011-080 011-077 011-079 011-071
Item Tags :
011-E-0029
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480098.pid
Discipline: PRO
SA-JER-DS011-TRJR-480098 2271-011-PID-0021-037
REV:
05
Sheet: 3 of 3
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
FC 0155 A
37
37
L
FT 0155 A
36
36
35
1/2"
1/2"
1/2"
1/2"
35
INST. PIPING
34
34
33
33
FV 0155 +
31
MIN.
6"-HFO-011038003-103CL2P-S
30
3/4"
28
1/2"
1/2"
1/2"
1/2"
8"-HFO-011030002-101CL2P-S
24
FI
ZC
0155 B
0356
3/4"-HFO-011038014-103CL2P-S MIN.
103CL2P 101CH2S
UC
3/4"
MIN.
LPT
1-1/2"
5
CL600 CL600
/4" 1"x3
3/4"-HFO-011038012-103CL2P-S
1-1/2"
CL600
1"
NOTE 4
ZC 0356
2"x1-1/2" TYP. 3
3/4"-OLW-011038301-101CS1P-N
0316 MG 0016 A
103CL2P 101CH2S
/4" 1"x3
M 3/4"-HFO-011038013-103CL2P-S
ZC
MCC TYP.3 103CL2P 101CH2S
25
25
2869
2868
9- DELETED.
SIGNAL FROM LC 0046
DS011-TRJR-480024 3166
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
4034
1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPOROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPOROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPOROVED FOR CONSTRUCTION
MSS / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MMG / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS.
2
DS011-TRJR-480080
OLW
INSULATION: S
3- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 4- DISMOUNTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION. 6- FLANGED GLOBE VALVE TYPE. 7- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JER-DSO11-TRJR-480247. 8- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DSO11-TRJR-480274.
4
TO 011-E-0015
011-G-0016-A / B MVGO PUMPS
NOTES
5
3
2"-CLD-011038302-101CH2S-P
5 DELETED. 1- PROVIDE A STRAIGTH LENGTH OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 2- CHECK VALVE SHALL BE INSTALLED HORIZONTALLY.
6
NOTE 4
3/4"-OLW-011038302-101CS1P-N
2"-CLD-011038301-101CH2S-P
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
7
MVGO
2"x1-1/2"
GENERAL NOTES
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
MIN.
OLW
DS011-TRJR-480080 3312
m³/h barg bar barg °C kg/m³
8
3/4"
MG 0016 B
FROM 011-C-0003
011-G-0016-A / B CENTRIFUGAL 146.0 19.60 16.69 30.00 267.00 775.0
9
0316
MVGO
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
10
1-1/2"-HFO-011038013-103CL2P-S 103CL2P 101CS1P
MCC
11
6"x3"
CL600
MIN.
250mm MIN.
8"-HFO-011030002-101CL2P-S
ZC
011-G-0016-B . NOTE 7
3/4"
MIN.
0356
2
3/4"
NOTE 1 8"x6"
1-1/2"-HFO-011038012-103CL2P-S
ZC
0088
M
1"
3/4" 3/4"
PI
LPT
4 3
101CS1P 103CL2P
6"x3"
PIPING
12
6"-HFO-011038003-103CL2P-S
MIN.
6
2241
INST.
13
103CL2P 101CS1P
NOTE 1 8"x6"
FLO
PI 0247
NOTE 2
MIN.
011-G-0016-A . NOTE 7
7
PIPING 3/4" 3/4"
PI 0087 3/4"
NOTE 2
16
250mm MIN.
0236
LPT
1
2"-FLO-011038303-101CS1P-N
INST.
PI
NC
NOTE 3
1-1/2"-HFO-011038013-103CL2P-S
8
17
14
NOTE 6 3/4"
MIN.
9
18
15
INST.
2240
10
19
D
PIPING
FLO
3/4"
3/4"
8"-HFO-011038002-103CL2P-S
11
NOTE 6
1-1/2"-HFO-011038012-103CL2P-S
12
D
8"-HFO-011038001-103CL2P-S INST. PIPING
13
101CS1P 103CL2P
2"-FLO-011038302-101CS1P-N
14
20
4996
MIN. NOTE 3
3/4"
21
25
LPT
MIN.
15
23
2"-HFO-011038002-103CL2P-S
2"-HFO-011038001-103CL2P-S
16
2"-CLD-011038303-101CH2S-P
MIN.
MIN.
MIN.
MIN.
MIN.
3/4"
MIN.
17
24
22
19 18
25
3/4"
2"x3/4"
MIN.
UC
26
3/4"-HFO-011038009-103CL2P-H
21 20
DV
250mm MIN.
22
28 27
3/4"-HFO-011038011-103CL2P-S
101CL2P 103CL2P
101CL2P 103CL2P
6"x4"
NC
LL
23
4"
011-SC-0046 TYPE 7 NOTE 8 SC STOP PUMP
6"-HFO-011038007-103CL2P-S
31 30
6"x4"
PIPING INST.
FT 0155 B
8"-HFO-011030002-101CL2P-S
FC
29
26 25
32
6"x4"
MIN.
29
27
4"
6"x4"
MIN.
32
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080 011-077
Item Tags : 011-G-0016-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 MVGO PUMPS ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480099.pid
Discipline: PRO
SA-JER-DS011-TRJR-480099 2271-011-PID-0021-038
REV:
05
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
011-E-0030-A / B HVGO COOLER
40
40
INSULATION (SHELL / TUBE): H / H TRIM: PRW-011038601-106CS2P / HFO-011038601-106CS1P
39
39
38
38
8"-HFO-011008001-103CS1P-S 2"-HFO-011038022-103CS1P-S
37
LPT MIN.
2"
+
2"-PRW-011038002-101CS2P-N
MIN.
33
MIN.
34
2"-HFO-011008001-103CS1P-S
103CS1P 101CH2S
3/4"
D
TZV 0005
FLO
D
36
3/4" 10"x8"
FLO 7776
2207
2"x1"
2"-HFO-011040120-103CS1P-S MIN.
35
12"-HFO-011008001-103CS1P-S 34
12"x10"
NOTE 4
33
3/4"
3/4"
32
2"-FLO-011038307-101CS1P-N
2"
+
2"-FLO-011038304-101CS1P-N
103CS1P 101CS1P
2"
35
NOTE 12
TI
D
0172
31
2"-PRW-011038005-103CS2P-P FB LO
V
MIN.
36
1"D2" 22.72
101CS1P 103CS1P
37
3/4"
32
D
NOTE 8
31
HPT 2"
30
TT 0172
14"
2"-FLO-011038305-101CS1P-N
10"
B3
011-E-0030-A
27
B4
A3
0331
25
CL600 CL300 10" 14"
CL300
D
10" CL600 2"
+
14"x12"
TC 0173
12"x8" 103CS2P 101CS2P
TT 0169
2"
12"-PRW-011038004-103CS2P-H
TT 0173
3/4" D
16
NOTE 11
8"-HFO-011038021-103CS1P-S
MIN.
3/4"
13
PIPING INST. 12
LPT
D
101CS1P 103CS1P
7777
8
2"
2"-HFO-011038023-103CS1P-S
103CS1P 101CH2S
2"-CLD-011038307-101CH2S-P
5 25
4
2604
0202
18
6977
MIN.
2"-FLO-011038306-101CS1P-N 2"
17
CL600
3/4" 8"x6"
FT 0050 B
8"x6" 13
6" NC
12
MIN. 3/4"
2"x3/4" D
19
16
2"-HFO-011038015-103CS1P-S MIN. 2"
7 6
FC
3/4"-HFO-011038016-103CS1P-S
MIN.
20
15
1/2"
3/4"
2"-CLD-011038307-101CH2S-P
D
2"-FLO-011038308-101CS1P-N FLO NOTE 13
MIN.
6" 8"x6"
L
14
PC 0338
10
3/4"
3/4" D
8"x6"
25 9405
9
+
21
TT FLO
PV 0338
1/2" 1/2" NOTE 10
1/2"
103CS1P 101CH2S
2"-CLD-011038309-101CH2S-P
2"-HFO-011038005-103CS1P-S 2"
12"x10"
2" D
PT 0338
11
FT 0050 A
10"x8" 8"-HFO-011038005-103CS1P-S
MIN.
H
TI 0202
LPT
15 14
22
FI 0050
11 10 9
103CS1P 101CH2S
25 4997
8
8"-HFO-011038005-103CS1P-S
17
12"x8"
A1
14"
TV 0173
011-E-0030-B
B2
MIN.
18
TI 0169
8"
101CS2P 103CS2P
19
3/4"-HFO-011038018-103CS1P-S
20
FO 8" NC NOTE 3
A2
23
MIN.
B1
12"x8"
2"-HFO-011038024-103CS1P-S
22 21
0332
CL600
103CS1P 101CS1P
TW
MIN.
3/4"
250mm MIN.
12"x8" 23
24
2"-CLD-011038304-101CH2S-P
SC
2"-HFO-011038020-103CS1P-P MIN.
NO
3/4" V
011-SC-0008
TYPE 7
MIN.
24
NOTE 9
250mm MIN.
25
26
UC
TW
MIN.
MIN.
3/4"-HFO-011038017-103CS1P-S
6976
3/4" D
28
A4
FLO
27 26
29
14"x12"
MIN.
12"x8"
V
MIN.
2"
30
12"-PRW-011038003-103CS2P-P
250mm MIN.
2"-HFO-011038004-103CS1P-S
28
103CS1P 101CS1P
MIN 29
2"
7 6 5 4
3
3
3/4"-HFO-011038018-103CS1P-S
2
COLD HVGO
HVGO FROM 011-E-0010 DS011-TRJR-480016 2956
ATM RESIDUE
ATM RESIDUE
FROM 011-G-0022
FROM 011-E-0031
TO STORAGE
DS011-TRJR-480104
DS011-TRJR-480124 3482
DS011-TRJR-480104 7828
DS011-TRJR-480104 7827
8306
HOT HVGO
TEMPERED WATER
TEMPERED WATER
TO DHC/MHC
TO 011-A-0007
DS011-TRJR-480137 3478
DS011-TRJR-480124 3481
DS011-TRJR-480138 3483
2"-CLD-011038304-101CH2S-P
12"-HFO-011038023-103CS1P-S
12"-HFO-011040120-103CS1P-S
12"-PRW-011052003-101CS2P-H
12"-PRW-011038001-101CS2P-P
12"-HFO-011038004-103CS1P-S
12"-HFO-011008001-103CS1P-S
1
CLOSED DRAIN
05
13-MAR-2013
AB
04
30-SEP-2011
03
GENERAL NOTES
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-E-0030-A / B AES 12.60 4.50 160.00 65.00 90.00 85.00 30.00 23.10 210.00 150.00 458.8 11.37
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
POS. 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 NOTES 4 1,2,5,6,7 DELETED. 5 3- VALVE TV-0173 TO BE SUPPLIED WITH A SOFT LIMIT STOP TO ENSURE A MINIMUM OF 52.4 m³/h THROUGH THE HEAT EXCHANGER. 6 4- AT GRADE. AT SAFE LOCATION. 7 8- BLOCK VALVE SHALL BE INSTALLED WITH STEM IN OR BELOW THE HORIZONTAL POSITION. 8 9- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS011-TRJR-480274. 10- HIGH RANGEABILITY: FT-0050A LOW FLOW RANGE, AND FT-0050B HIGH FLOW RANGE. 9 11- LINE TO BE USED WHEN 011-E-0010 IS BYPASSED. 10 12- SET PRESSURE READJUSTED BASED ON DISTANCE FROM UPPER TL OF E-0030 TO TZV. ELEVATION DIFFERENCE SHOULD NOT BE HIGHER THAN 4.0 m. 11 13- DELETED. 12 13 14 15 16 17 18
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / FBL
RDP/ MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
VJS / FCB
RDP/ MAC
JAL
DATE
UTILITIES IDENTIFICATION DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
1
AB: AS BUILT
REV
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
2
TO STORAGE
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VGO COOLER
011-074 011-076 Item Tags :
011-075 011-080 011-077
ORIGINAL SIGNED IN PROJECT FILE 011-E-0030-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480100.pid
Discipline: PRO
SA-JER-DS011-TRJR-480100 2271-011-PID-0021-038
REV:
05
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
MIN.
37
37
18"-HFO-011039003-103CL2P-S
18"-HFO-011039003-103CL2P-S
36
36
4"-FLO-011039301-101CS1P-N 3/4"
101CL2P 101CS1P
35
V
34
FLO 2234
NOTE 1
33 32
28"x20"
31
28"x20"
20"-HFO-011030001-101CL2P-S
UC
30
20"-HFO-011030001-101CL2P-S
NOTE 3
NOTE 3
18"x16"
UC 0303
0303
NOTE 3
NOTE 3
UC
UC
0304
0304
35
18"-HFO-011039010-103CL2P-S
4"-HFO-011030001-101CL2P-S
34 33 32 31
18"x16"
30
29
29
OPEN
S
103CL2P FC TSO NOTE 3
DE
XLC 0029
XLS 0029 O
XLS 0029 C
OPEN
XV 0030
XLO
XYV 0031
+
S
OPEN
DE
0030
0031
ATM
MIN.
XLS
0030 O
0030 C
XYV 0032
101CL2P 103CL2P FC TSO NOTE 3
DE
OPEN
S
CLOSED IA XLC
XLO 0032
28
FC TSO
DE
27 26
0032
ATM XLS 0031 O
XV 0032 +
+
0031
ATM XLS
S
CLOSED IA XLC
XLO
XV 0031 +
+
FC TSO
CLOSED IA XLC
0030
25 24
XYV 0030 +
CLOSED IA
XLO 0029
26
101CL2P
+
MIN.
27
XV 0029
ATM
XLS 0031 C
XLS
XLS
0032 O
0032 C
MIN.
28
+
MIN.
XYV 0029
25 24
NOTE 7
23
LPT
MIN.
NOTE 7 LPT
MIN.
MIN.
23
MIN.
FLO
15
H
PDI 0106
2236
NOTE 6
INST. PI 0368
12
PIPING
PDT
3/4" 3/4"
0106
11
3/4" 3/4"
PI 0089
3/4"
3/4"
3/4"
3/4"
INST. PI 0369
INST.
10
PDT
3/4" 3/4"
3/4"
3/4"
3/4"
3/4"
3/4"
/4" 2"x3
2"
M
PIPING
INST.
MIN.
MIN.
8
011-G-0017-A 3/4"
NOTE 2, 11
12
1/2"
INST. PIPING
10
NOTE 10
MIN. 2"
11
16"x10"
NOTE 5 20"x16"
NOTE 10
MIN.
13
0090
20"x16" 9
14
PIPING 3/4" 3/4"
PI
0107
16"x10"
NOTE 5
" 3/4 2"x
011-G-0017-B
M
NOTE 2, 11
7 6
2"-HFO-011039011-103CL2P-S
2"-HFO-011039012-103CL2P-S MIN.
1
0311
103CL2P 101CH2S
UC
MG
0303
0017 A
2"-CLD-011039301-101CH2S-P
NOTE 12
3/4"-OLW-011039001-101CS1P-N
0311 103CL2P 101CH2S UC 0304
ZC 0334
MXL G0017 AB
MXS NOTE 10 G0017 AB
25
ZC 0336
2867
ZC 0334
0017 B
MXL G0017 BB
011-G-0017-A / B HVGO PUMPS
3/4"-OLW-011039002-101CS1P-N
2"-CLD-011039302-101CH2S-P
25
MXS G0017 BB
2866
DS011-TRJR-480081 3373
NOTES
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
m³/h barg bar barg °C kg/m³
05
13-MAR-2013
AB
011-G-0017-A / B CENTRIFUGAL 1610.0 19.90 17.59 30.00 322.00 775.0
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
4 DELETED 1- FOR THE FILLING PURPOSE. 2- FUSIBLE TUBING TO BE ADDED AROUND PUMP FOR FIRE DETECTION. 3- CLOSING SUCTION OR DISCHARGE VALVE AUTOMATICALLY STOPS ASSOCIATED PUMP (VIA DCS) UC 0303/0304 IN CASE OF LOSS OF OPEN POSITION. 5- PROVIDE A STRAIGHT LENGTH OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 6- CHECK VALVE SHALL BE INSTALLED HORIZONTALY. 7- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 8- DISMONTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION. 9- FLANGED GLOBE VALVE TYPE. 10- LOST OF PUMP RUNNING INDICATION WILL BE TRIGGER ZC-0334. 11- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JER-DS011-TRJR-480245. 12- THIS MOTOR WILL INCLUDE A SOFTWARE TRIP PUSH BUTTOM INSTEAD FO A HARDWIRED FROM MCR AUX. PANEL AS PER JERES-C-102 AND JERES-J-601 13- DELETED.
DS011-TRJR-480141 3485
DS011-TRJR-480028 3210
2 1
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR/ STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT/ STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MSS / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JGT / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
DATE
UTILITIES IDENTIFICATION 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
HVGO PA TO 011-E-0019
AB: AS BUILT
REV
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
HVGO PA TO 011-S-0001
OLW
NOTE 10
POS.
5
3
FROM 011-C-0003
GENERAL NOTES
6
4
INSULATION:
HVGO
7
MG
OLW ZC 0336
8
NOTE 8
MCC MIN.
101CS1P
ZC
TYP. 6
ZC
250mm MIN.
2
0357
MCC 103CL2P
28"-HFO-011030001-101CL2P-S
0357
ZC
NOTE 8 MIN.
ZC 3
TYP. 6
NOTE 12
250mm MIN.
4
9
MIN.
103CL2P 101CS1P
5
HVGO TO 011-S-0002 4238 16 15
INST.
PIPING
PIPING
18
H
PDI 0107
1/2"
INST. PIPING
19
6"-HFO-011039004-103CL2P-S
2237
INST. PIPING
NOTE 6
17
FLO
14 13
3/4" NOTE 9
20
18"-HFO-011039003-103CL2P-S
16
NC
D
21
10"-HFO-011039005-103CL2P-S
17
3/4" NOTE 9
3/4"
20"-HFO-011039002-103CL2P-S
18
D
2"-HFO-011039002-103CL2P-S
101CS1P 103CL2P
19
3/4"
20"-HFO-011039001-103CL2P-S
20
101CS1P 103CL2P
2"-FLO-011039302-101CS1P-N
2"-HFO-011039001-103CL2P-S
2"-FLO-011039303-101CS1P-N
21
2"-HFO-011039012-103CL2P-S
22
2"-HFO-011039011-103CL2P-S
22
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
FLUSHING OIL
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 HVGO PUMPS
011-074 011-076 Item Tags :
011-075 011-080 011-077
ORIGINAL SIGNED IN PROJECT FILE
011-G-0017-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480101 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480101 2271-011-PID-0021-039
REV: 05
Sheet: 1 of 3
SCALE: NONE Format:
A1
41
41
011-S-0002 HVGO INTERNAL REFLUX FILTERS
40
40
TRIM: HFO-011039610-103SD0P
39
39
NOTE 5 38
1"D2" 29.10
38
+
37
PZV 0070
CL300 3/4" V NOTE 3 3"x2"
+
36
3"-LFL-011039301-101CH2F-N
2"x1" 3/4"
2063
PDI
H
0091
29
V
3/4" 2"
2"-HFO-011039014-103SD0P-S
2"
28
34 33
103SD0P 101CH2F
NOTE 6
32
30
35
2"
LO FB
31
36
29
NOTE 2
34 33
0.2 %
LO FB
CL600
35
37
32
NC
MIN.
31 30 29 28
PDT 0091
27
27
26
26
MIN.
MIN.
FC 0051 A
V
W
3/4" 6" CL600
6"
PI 0317
FT 0051 A 1/2"
1/2"
1/2"
1/2"
FV 0051
INST. PIPING
NOTE 7
+
17
1/2"
1/2"
14
PIPING 13
FO
6"-HFO-011039004-103CL2P-S
2"
15
NC MIN.
3/4"
FI 0051 B L
MIN.
H 2"x3/4"
250mm MIN.
103CL2P 101CH2S
8 7
2"-CLD-011039304-101CH2S-P
MIN.
5
14
PIPING
INST. 13
3/4"-OLW-011039003-101CS1P-N
103SD0P 101CH2S
3/4" 3/4" PIPING
PT 0041
PI 0041
12
H
11
INST. 10
OLW 9 8
25 2911
LPT
6"-HFO-011039019-103SD0P-S
7
6"-HFO-011039007-101SD0P-S
6
MIN.
2"-CLD-011039303-101CH2S-P
PI 0318
101CS1P
2"-HFO-011039015-103SD0P-S
6"x2"
3/4"-HFO-011039017-103CL2P-S
6
17 16
MIN.
0051 B
9
18
3/4" 3/4"
6"x2"
11
3/4"
INST. PIPING
3/4"
103SD0P
FT
10
2"
4"x2"
1/2"
1/2"
TI 0473
3/4"
INST.
12
2"-HFO-011039022-103SD0P-S
MIN.
MIN.
15
3/4" 3/4"
6"-HFO-011039018-103SD0P-S 19
4"x2"
4" 6"x4"
6"x4"
20
3/4" D
3/4" 3/4"
4"
HVGO 6"-HFO-011039004-103CL2P-S 4238FROM 011-G-0017-A/B
MIN. 3/4" D
21
6"-HFO-011039006-101SD0P-HA
103SD0P 101SD0P
PIPING 18
D
A B S D 2" 2" CL600 CL600
22
103CL2P 103SD0P
INST.
6"-HFO-011039013-103CL2P-S
19
3/4"
UC 2"
103CL2P 103SD0P
20
3/4"
CL600
INST. PIPING
MIN.
21
16
D
23
250mm MIN.
22
3/4"
24
0453 2"
CL600
2232
PI
NOTE 1 M1 12"
2" CL600 103CL2P 103SD0P
FLO
23
011-S-0002
2"-HFO-011039004-103CL2P-S
2"-FLO-011039304-101CS1P-N 101CS1P 103CL2P
24
25
2" V
103SD0P 101SD0P
25
25
5
5000
4
4
3
3
3/4"
3/4"-HFO-011039016-103CL2P-S 2"x3/4"
3/4"
D
MIN.
2233
1
2"-HFO-011039013-103CL2P-S 101CS1P 103CL2P
FLO
2"-FLO-011039305-101CS1P-N
6"-HFO-011039008-101SD0P-S
MIN. 2
103CL2P 101CH2S
2"-CLD-011039305-101CH2S-P
1
250mm MIN.
MIN.
2
WASH OIL
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
VJS / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
TO 011-C-0003 DS011-TRJR-480081 3372
25 2909
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1, 3 DELETED. 2- MAKE CONNECTION ON TOP OF LINE. 4- DES. PRESS (barg): 30.0 + FV. 5- SET PRESSURE READJUSTED BASED ON DISTANCE FROM UPPER TL OF S-0002 TO PZV. ELEVATION DIFFERENCE SHOULD NOT BE HIGHER THAN 11.8m. 6- GATE VALVE SHALL BE INSTALLED WITH STEM IN OR BELLOW THE HORIZONTAL POSITION. 7- EMERGENCY CONNECTION (PYROPHORIC SERVICE) TO BE AT GRADE. 8- DELETED FILTERS TYPE DES. CAPACITY OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP.
m³/h barg °C barg °C
011-S-0002 BASKET 130.0 3.20 322.00 30.00 NOTE 4 355.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 HVGO INTERNAL REFLUX FILTERS
011-074 011-076 011-075 011-080 011-077
Item Tags :
ORIGINAL SIGNED IN PROJECT FILE
011-S-0002
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480102.pid
Discipline: PRO
SA-JER-DS011-TRJR-480102 2271-011-PID-0021-039
REV:
05
Sheet: 2 of 3
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
37
36
36
MIN. 35
33
D
16"-HFO-011030101-103CL4P-S
30
DE
IA
FC TSO
DE
ATM
XLO
XLC
0006
0006
XLS 0006 O
XLS 0006 C
23
MIN.
XLS 0007 O
IA DE
1"
PIPING
16 15 14 13
16"-HFO-011039101-103CL4P-S
INST.
XLS
0008 O
0008 C
24
MIN.
23
NOTE 6
22
2"-HFO-011039102-103CL4P-S
2229
PI
PDI 0108
INST.
NOTE 2
1"
0371
INST. INST.
1/2" 1"x1/2" H
UC
D
1"
PIPING
NOTE 5
1"
2" 1"
PIPING 1" 1"
INST. PI 0092
1"
FLO
PIPING
PI 0093
PIPING 1" 1"
INST.
PIPING
H
PDI 0109
1"
1" 16"x12"
H
5
2" 2"
TT
TC
0204
0204
M
NOTES 2, 5, 10
MCC
ZC 0306
TYP. 6
1"-OLW-011039004-101CS1P-N
SIGNAL TO FC-0063-A
FROM 011-C-0003 DS011-TRJR-480081 3366
DS011-TRJR-480027 4056
TO 011-C-0003
2865
m ³/h barg bar barg °C kg/m³
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
17 16
4"x2"
2"
25
VACUUM RESIDUE TO 011-E-0037 DS011-TRJR-480136 7802
MIN.
15
1" D
TYP. 6
13
103CL4P 101CS1P
103CL4P 101CH2S
SIGNAL
VACUUM RESIDUE
011-G-0018-A / B VACUUM RESIDUE PUMPS
25 2860
INSULATION: S
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER 4 POTABLE WATER NOTES 5 DEMI WATER 8 DELETED. 6 N.A. 1- FOR THE FILLING PURPOSE. 7 N.A. 2- FLANGED GLOBE VALVE TYPE. 8 N.A. 3- TIE-IN FOR ANTI-FOULING AGENT. 9 HP STEAM 4- PROVIDE A STRAIGTH LENGTH OF PIPE AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 5- CHECK VALVE SHALL BE INSTALLED HORIZONTAL. 10 MP STEAM 6- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 11 LP STEAM 7- DISMONTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION. 12 HP CONDENSATE 9- CLOSING SUCTION OR DISCHARGE VALVES AUTOMATICALLY STOP ASSOCIATED PUMP (VIA DCS UC-0311 / UC-0312) IN CASE OF LOSS OF OPEN POSITION. 13 MP CONDENSATE 10- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JER-DS011-TRJR-480247. 14 LP CONDENSATE 11- DELETED. 15 BFW 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A.
06
13-MAR-2013
AB
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
9 8
FLO
6
9409
5 4
05
06-OCT-2011
04
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
ATM RESIDUE
TO 011-E-0020
FROM 011-G-0014
DS011-TRJR-480081 7806
DS011-TRJR-480029 3223
DS011-TRJR-480066 3293
2 1
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUTION
JMV / STG
AVS / MAC
JAL
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUTION
NPS / STG
AVS / MAC
JAL
02
30-NOV-2010
AFC
AFC: APPROVED FOR CONSTRUTION
MSS / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
NPS / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
DATE
UTILITIES IDENTIFICATION 011-073 011-072 011-073 011-071
10
AB: AS BUILT
REV
REF. DWG POS.
11
7
VACUUM RESIDUE
FROM HS-0010
DS011-TRJR-480066 3294
OLW
UC 0312
12
3
NOTE 7
OLW
14
1"-OLW-011039005-101CS1P-N
2"-CLD-011039307-101CH2S-P
DS011-TRJR-480081 3371
MIN.
TO 011-F-0002
0018 B
25
/B
103CL4P 101CH2S
MCC
0018 A
GENERAL NOTES
011-G-0018-A CENTRIFUGAL 636.0 17.50 16.69 28.00 360.00 880.0
2"x1"
7819
MG
PUMP VENT
18
1"
NOTES 2, 5, 10
2"
ZC 0306
2"-CLD-011039306-101CH2S-P VACUUM RESIDUE
FC 2"
011-G-0018-B
MG
0311
4"x2"
4"x2"
12"x10"
M
ZC 0352
MIN. UC
LPT NOTE 4
2"-HFO-011039108-103CL4P-S
NOTE 7
103CL4P 101CH2S
4"x2"
19
1"
MIN.
250mm MIN.
2"-HFO-011039105-101CL4P-S
1"
3/4"
ZC 0352
18"-HFO-011030101-103CL4P-S
1"
011-G-0018-A
0203
1
1"
INST. PIPING
16"x12"
2"-HFO-011039107-103CL4P-S
2
1"
2"
3/4"
6
TT
MIN.
12"x10"
103CL4P 101CS1P
TI 0203
MIN.
8
LPT NOTE 4
+
103CL4P 101CS1P
1"
2"x1"
MIN.
1"
1"
LV 0050
MIN.
INST. PIPING
10 9
PDT 0109
2"x1"
20
250mm MIN.
PDT 0108
11
21
D
MIN.
1/2" 1"x1/2"
2"-HFO-011039105-101CL4P-S
12
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
XLS
MIN.
UC
NOTE 5
0370
17
4"-HFO-011039109-103CL4P-S
MIN.
PI
NC NOTE 2
1"
2"-FLO-011039308-101CS1P-N
101CS1P 103CL4P
LPT 2"
D
1"
26
FC TSO
12"-HFO-011027105-103CL4P-S
18
1"
XLC 0008
27
1" D
25
ATM
XLS 0007 C
XLO 0008
NOTE 11
2220
+
LPT
2"-HFO-011039107-103CL4P-S
2228
FC TSO
OPEN
XV 0008
NOTE 6
2"-FLO-011039307-101CS1P-N
101CS1P 103CL4P
FLO
19
3
S
ATM CLOSED
MIN.
2"-HFO-011039101-103CL4P-S
20
4
XLC 0007
+
MIN.
21
7
XLO 0007
XV 0007
SHORT RECIRCULATION
22
CLOSED
+
10"-HFO-011039104-103CL4P-S
XLS 0005 C
MIN.
XLS 0005 O
OPEN
ATM CLOSED
FC TSO
OPEN
XYV 0007
2"-FLO-011039310-101CS1P-N
IA
25 24
+
4"-HFO-011039110-103CS1P-S
S
XV 0006
28
103CL4P 103CS1P
XLC 0005
+
FLO
MIN.
XLO 0005
XV 0005
2"-HFO-011039104-103CL4P-S 2"-FLO-011039309-101CS1P-N
MIN.
CLOSED
+
MIN.
26
OPEN
XYV 0005
S
DE
VDU BYPASS
+
NOTE 3 27
XYV 0006
IA
UC 0312
29
MIN.
2"
NOTE 9
S
30
MIN.
1"-HFO-011039111-103CL4P-S
28
UC 0311
NOTE 9
MIN.
NOTE 9
+
UC 0311
18"x16"
16"-HFO-011039102-103CL4P-S
29
XYV 0008
31
MIN.
18"x16"
NOTE 9
0312
101CS1P 103CL4P
UC
31
32
12"-HFO-011039106-103CL4P-S
32
250 mm MIN.
1"
34
2"-CLD-011039308-101CH2S-P
33
12"-HFO-011039103-103CL4P-S
VDU BYPASS
2227
4"-FLO-011039306-101CS1P-N NOTE 1
2"-HFO-011039108-103CL4P-S
FLO
101CS1P 103CL4P
34
35
4"-HFO-011030101-103CL4P-S
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM RESIDUE PUMPS
011-074 011-076 Item Tags :
011-075 011-080 011-077
ORIGINAL SIGNED IN PROJECT FILE
011-G-0018-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480103.pid
Discipline: PRO
SA-JER-DS011-TRJR-480103 2271-011-PID-0021-039
REV:
06
Sheet: 3 of 3
SCALE: NONE Format:
A1
41 40
101CS1P 103CS1P
2"-FLO-011040301-101CS1P-N
LO 2"-HFO-011040105-103CS1P-S
2"-HFO-011040102-103CS1P-S
2219
2"-FLO-011040303-101CS1P-N
D
3/4"
3/4" D
MIN. 36
MIN.
MIN.
2223
37
35
MIN.
33
34
2"-FLO-011040304-101CS1P-N
33
FLO 2224
32
10" A3 PS1
MIN.
2"
3/4" V
25
MIN.
18 17
MIN.
LPT
103CS1P 101CH2S
3/4"-OLW-011040303-101CS1P-N 2"-CLD-011040308-101CH2S-P NOTE 7 011-SP-0003
LPT
OLW
16
25
LPT
LPT
011-SP-0002 NOTE 7
2602
3/4"-BFW-011040008-101CS1P-H
3/4" FC 0052
3/4"
8"x6"
NOTE 14
8"x6"
6"
VACUUM RESIDUE FROM 011-E-0014 DS011-TRJR-480019 3106
3/4"-HFO-011040123-103CS1P-S 2"x3/4"
103CS1P 101CH2S
3/4"-HFO-011040110-103CS1P-S 3/4"
2"-CLD-011040313-101CH2S-P
MIN.
AT 2"x3/4"
3/4"
103CS1P 101CH2S
MIN.
MIN.
PIPING INSTR.
2"-CLD-011040302-101CH2S-P
0015 NOTES 6, 12 INSTR. PIPING
HS 0053 A
25
25
7834
5001
MIN. 2"-HFO-011040121-103CS1P-S
FY 0053 A
7840
FLOW VALUE UC FY 0053 B 0322 C
DS011-TRJR-480137 3486
SIGNAL FROM HS-0005
SIGNAL FROM HS-0010
DS011-TRJR-480044
DS011-TRJR-480081
LEVEL HS-0053 FROM FRAGTIONATOR OF COKER UNIT MAN 021 DS011-TRJR-480137
4171
4061
3778
GENERAL NOTES 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DS011-TRJR-480001 THROUGH SA-JER-DS011-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-E-0031-A / B BES 12.70 2.60 205.00 140.00 180.00 141.00 28.00 21.50 311.00 170.00 669.0 4.80
NOTE 9 NOTE 4
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
1,2,3,5,10 DELETED. 4- FULL VACUUM @ 170°C ON TUBE SIDE. 6- LOCATED IN ANALYZER SHELTER 011-AS-0002 SEE PID SA-JER-DS011-TRJR-480290. 7- LOCATE BUTTERFLY VALVE AS CLOSE AS POSSIBLE TO 011-E-0031A/B. PROVIDE ADJUSTABLE MECHANICAL MINIMUM STOP. 8- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-08011-TRJR-480273. 9- PRESSURE IN DRUM ABOVE THE LIQUID LEVEL. PRESSURE AT INLET NOZZLE = 30 barg 11- CONTROL VALVE OPERATES AS AN OFF/ON CONTROLVALVE. 12- FOR ANALYZER HOOK UP REFER TO SA-JER-DS011-DSDB-210014 (SHEET 4). 13- DELETED. 14- THIS LINE SHALL BE TRACED WITH MPS. 15- ANALYZER SAMPLE PROBE INCLUDED.
16"x12"
12"x6"
FC
2"
3/4"
3/4"
3/4"
12"x8"
12"x8"
8"
12"x6"
15 14
FLO 6374
13 12 11 10 9
12"x6"
6"
3/4"-HFO-011040122-103CS1P-S
3/4"
103CS1P 101CH2S
25 7846
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
MIN.
3/4" 2"x3/4"
103CS1P 101CH2S 2"-CLD-011038304-101CH2S-P
7 6 5 4 3
CLOSED DRAIN
VACUUM RESIDUE
DS011-TRJR-480100
TO STORAGE
8306
DS011-TRJR-480138 3487
2 1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
30-NOV-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
AVS / MAC
JAL
ATM RESIDUE
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / JLM
RDP / MAC
JAL
TO 011-E-0030
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
VJS / JLM
RDP / MAC
JAL
DS011-TRJR-480100 7828
REV
FROM 011-E-0030
DATE
UTILITIES IDENTIFICATION POS.
NC
3/4"-HFO-011040109-103CS1P-S
ATM RESIDUE
NOTE 14
NOTES
6"
2"x1" 3/4" D
DS011-TRJR-480100 7827
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001).
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
2"-CLD-011040311-101CH2S-P
FY 0053 C
0015 A
12"x6"
CO
3/4"
25
TO COKER UNIT
12"x8"
MIN.
103CS1P 101CH2S
1"-HFO-011040125-103CS1P-S
12"x8"
MIN.
5002
AI
3/4" D
16
8
25
VACCUM RESIDUE
HFO-011010003 DS011-TRJR-480019 10780
MIN.
2"-FLO-011040306-101CS1P-N
250mm MIN.
011-SC-0023
3/4"-HFO-011040113-103CS1P-S
MIN.
SC
NOTE 8 TYPE 15
250mm MIN.
1
3/4"-HFO-011040014-103CS1P-S
10"-HFO-011010103-103CS1P-S
3
2"-CLD-011040301-101CH2S-P
NOTE 15
3/4" D
MIN.
+
2"x3/4"
103CS1P 101CH2S
2"
4
2
6986
BOILER FEED WATER FROM 011-D-0011 4252
FV 0053
3/4"
TT 0177
3/4"
2"x3/4"
MIN.
3/4"
10"
FLO
H
TI 0177
MIN.
3/4"
FC
D
3/4"
6" 10"x6"
10"-HFO-011010103-103CS1P-S
3/4"
MIN.
MIN.
MIN.
5
10"x6"
1"-HFO-011040124-103CS1P-S
10"x8" CO
MIN.
10"x8"
10"-HFO-011010103-103CS1P-S
103CS1P 101CS1P
+
6
OLW
MIN.
6"-BFW-011040001-101CS1P-H
NOTE 13
0053
PIPING 2" INSTR.CL600
3/4"-HFO-011040108-103CS1P-S
NOTE 13
MIN.
FV 0052
10ø MIN.
3/4"
NC
7
3/4"-OLW-011040309-101CS1P-N
10"
FT 0052
8
BOILER FEED WATER4251 FROM 011-D-0011
FT
CL600 2"
OLW
OLW
6"-BFW-011040002-101CS1P-H
2"-HFO-011040106-103CS1P-S
TT 0175
MIN.
9
FC NOTE 11
17
2603
10"
3/4"-OLW-011040308-101CS1P-N
250mm MIN.
10
3/4"-OLW-011040302-101CS1P-N
MIN.
11
+
3/4"-BFW-011040007-101CS1P-H
10"-HFO-011040101-103CS1P-S
12
FC 0053
25
TC 0175
TV 0175
3/4"-BFW-011040003-101CS1P-H 13
18
MIN.
LO
LO
MIN.
14
19
2"-CLD-011040307-101CH2S-P
2"-HFO-011040118-103CS1P-P
15
20
2"-FLO-011040307-101CS1P-N
UC
D
2"-HFO-011040112-103CS1P-S
21
16"-HFO-011040106-103CS1P-S
103CS1P 101CH2S
3/4"
103CS1P 101CS1P
V
3/4"
19
MIN. 6" CL300
SAMPLE RETURN LINE
D
A4
2" PD1 3/4"-BFW-011040004-101CS1P-H
1"-HFO-011040125-103CS1P-S
2"-HFO-011040111-103CS1P-S
22
MIN.
3/4"
MIN.
12"x10"
250mm MIN.
MIN.
10"
MIN.
2" PT1 CL300
23
MIN.
A2 6"
5415
24
LPT
MIN.
25
25
MIN.
20
10"
2"-HFO-011040119-103CS1P-P
26
B3
011-E-0031-B
B1
10"-HFO-011040104-103CS1P-S
21
LPT
PS2
MIN.
22
2"
250mm MIN.
23
PS2 2"
MIN.
2"-CLD-011040310-101CH2S-P
24
UC
10"-HFO-011040103-103CS1P-S
250mm MIN.
103CS1P 101CH2S
27
MIN.
011-E-0031-A
MIN.
26
V
PIPING INST.
3/4"
HPT 2"
MIN.
2"
VDU BYPASS
MIN.
MIN.
28
12"-HFO-011038023-103CS1P-S
27
A1 PS1
250mm MIN.
10"
10"-HFO-011040101-103CS1P-S
2"-CLD-011040312-101CH2S-P
V
31
29
VDU BYPASS
2"
4245
30
250mm MIN.
HPT
2"-HFO-011040115-103CS1P-S 28
LOW PRESSURE STEAM TO 011-D-0011
12"-LPS-011040003-101CS1P-H
LO
12" CL300 B4
12"-HFO-011040106-103CS1P-S
3/4" D
29
2" PT2
TWO PHASE FLOW
10"-HFO-011040105-103CS1P-S
2"-HFO-011040101-103CS1P-S
2" PT2
MIN.
2221
12" CL300 B2
250mm MIN.
2"-FLO-011040302-101CS1P-N
NO POCKET
MIN.
2"-HFO-011040103-103CS1P-S
FLO
30
32
3/4" D
101CS1P 103CS1P
31
39 38
FLO
103CS1P 101CS1P
10"-HFO-011040102-103CS1P-S
4243
36
10"-HFO-011040105-103CS1P-S MIN. MIN. MIN.
LPT 35 34
LOW PRESSURE STEAM TO 011-D-0011
12"-LPS-011040002-101CS1P-H
TWO PHASE FLOW
NO POCKETS
103CS1P 101CS1P
FLO
MIN.
12"-HFO-011040120-103CS1P-S
37
40
INSULATION (SHELL / TUBE): H / H
39 38
41
011-E-0031-A / B VACUUM RESID STEAM GENERATOR
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
DESCRIPTION
19 N.A. 20 FUEL OIL 21 FUEL GAS 22 N.A. 23 N.A. 24 N.A. 25 CLOSED DRAIN 26 N.A. 27 L.P. NITROGEN 28 H.P. FLARE 29 L.P. FLARE 30 SOUR/ACID FLARE 31 PILOT GAS 32 AUX COOLING WATER FLO FLUSHING OIL AMD AMINE CLOSED DRAIN CND TURBINE CONDENSATE
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM RESID STEAM GENERATOR
011-074 011-076 Item Tags :
011-075 011-080 011-077 011-079 011-071
ORIGINAL SIGNED IN PROJECT FILE
011-E-0031-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480104.pid
Discipline: PRO
SA-JER-DS011-TRJR-480104 2271-011-PID-0021-040
REV:
05
Sheet: 1 of 2
SCALE: NONE Format:
A1
011-D-0011 STEAM DRUM
41
39
011-Y-0008 LP STEAM SUPERHEATED SILENCER
TRIM: LPS-011040601-101CS1P / LPS-011040602-103CS1P INSULATION: H
40
011-D-0013 BLOW DOWN DRUM
41
INSULATION: P 40
LOW PRESSURE STEAM / BFW 12"-LPS-011040002-101CS1P-H
39
4243FROM 011-E-0031-A
38
38
37
37
011-Y-0008 NOTE 15
36
36
55-100%
35
35
34
0094
H
PI 0382
101CS4P
101CS1P
+
12"-LPS-011040017-101CS1P-H 12"
NOTE 8
12"-LPS-011040301-101CS1P-H
2166
1" D
24
1" D
12"-LPS-011040016-101CS4P-H
23
8"
22
12"x8"
NC
PT 0382
TI
TT
0176
0176
CL 300
INST. PIPING 2"
2" 2" P1
12"x8"
3/4" CLOSE BFW INJECTION
20
HH
19
PI 0227
17
ZC
LI
LT
0373
0063
0063
D
V NC
1/4"
0064
24" ID M
6"-BFW-011040001-101CS1P-H
3/4"
1/2" CL 300 1/2"
D NC
A3 12"
FB LC
NOTE 19 FT 0054 A
6"-LPS-011040006-101CS1P-P
OLW FI 0054
27
2" V 6" 6"
26
3/4"-LPC-011040010-101CS1P-P
25 24 23
NOTE 16 1/4" D
3"
A2
21
B1
PIPING INST.
12"
22
011-D-0013
20
LT
011-SP-0001
19
INST. PIPING
2" D
A1
2"
2"
2"
1/4" D
S1
B2
3"
6"
011-D-0011 NOTES 3,13
2"-BDH-011040004-101CS1P-P
18
A1
2"
L3A B3 6"
B5
3/4"-BDH-011040003-101CS1P-P
2"-BDH-011040002-101CS1P-P
11
NOTE 20
28
NOTE 2 ATM
2"
FMC H
LC 0065
ZC 0373
L
17 16 15 14 13
2"-OLW-011040305-101CS1P-N 12
300mm
D
12
V 011-SP-0034 NOTE 18
2"
1/4"
NOTE 10 011-SP-0045
3/4"
NOTE 18
29
CL300
V1 W2 W1
2"
SC
6"x3" 3/4"
CL300
INST.
L1A 2" 2" L2A
2"
14
011-SC-0022 NOTE 17
V FB LO
30
8"x4" 8"-LPS-011040008-101CS1P-P NOTE 1
0065
2"
NOTE 21
D
3/4"
B1
2"
B4
13
3/4"
D 3/4"
INST. PIPING
D
TYPE 7
8"x4" 8"-LPS-011040007-101CS1P-P
6"x3" 3/4"
NC PIPING
31
+
L3B
2"x1-1/2" NOTE 11
4252
BOILER FEED WATER TO 011-E-0031-A
L
3/4"
PT 0227
3/4" D
NOTE 17 TYPE 7 3/4"-LPS-011040015-101CS1P-H
2"
2"
PZV 0029 NOTE 1
SC
1/2" INST. PIPING 1/2"
P3
PZV 0028
32
+
NC
10"
L1B
MAG LG
8"x6"
6"
011-SC-0024
2"x1-1/2"
15
6"-BFW-011040002-101CS1P-H
10"x8" FT 0054 B
8"x6"
L2B
2"
BOILER FEED WATER TO 011-E-0031-B
8"
3"L4" 7.00
+
2"
P2 2" 2"
INST. PIPING
18
4251
10"x8"
INST. PIPING
2" 2"
2"
21
16
PT 0094
NC
FC CL300
10ø MIN.
11
25
PI 0095
12"x10"
6" 10"x6" FC CL300 3/4" D
3/4" D
3/4"
PV 0332
26
10"x6"
NOTE 6
10"
ST
+
2"-ACS-011040001-101CS1P-P
101CS1P
+
3/4"
10"-LPS-011040001-101CS1P-H
27
PV 0094 A
0094
3/4" D
3"L4" 7.00
33
NO POCKETS
28
PC
OLW
NOTE 4 18930 mm
INST. PIPING
29
10"-LPS-011040004-101CS1P-H
RS
PT 0332
FC TSO CL300
3/4" D
NO POCKETS
PC 0332
30
10"-LPS-011040004-101CS1P-H
12"-LPS-011040003-101CS1P-H
LOW PRESSURE STEAM / BFW 4245 FROM 011-E-0031-B 31
6" 10"x6"
10"x6"
PY
NOTE 2 ATM
NOTE 2 ATM
3"-LPS-011040009-101CS1P-P
0-45% SPLIT RANGE
34
+
33 32
1"-OLW-011040307-101CS1P-P
PV 0094 B
2"-BDH-011040001-101CS1P-P
TWO PHASE FLOW
RESET
60º
FLOW
MIN.
101SD0P 101CS1P
DETAIL "A"
X
3/4" D
3"x1-1/2"
3
1
1" ø=33.4mm ext.
2mm
PHOSPHATE
TO 011-F-0002
FROM 011-X-0006
DS011-TRJR-480079 3306
DS011-TRJR-480128 3488
GENERAL NOTES
mm mm barg °C barg °C
011-D-0011 HORIZONTAL 4000.0 1700.0 2.60 140.00 7.00 +FV 170.00
011-D-0013 VERTICAL 2000.0 900.0 0.30 107.00 3.50 135.00
SILENCER TYPE FLOW OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP.
Kg/hr barg °C barg °C
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
011-Y-0008 DIFFUSER+ABSORP. 9200.0 0.60 140.00 3.50 170.00
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER NOTES 4 POTABLE WATER 7, 9, 12, 14 DELETED. 1- WEEP HOLE AT LOW POINT (10 mm). 5 DEMI WATER 2- TO ATMOSPHERE AT SAFE LOCATION. 6 N.A. 3- ENSURE THAT NOZZLES FOR LEVEL TRANSMITERS ARE AT THE SAME ELEVATION. 7 N.A. 4- DISTANCE BETWEEN LOWER TUBE SHEET OF STEAM GENERATORS 011-E-0031 AND LOWER TL OF 011-D-0011 IS 14.5M MINIMUM. 5- TI TO BE VISIBLE FROM VALVE. 8 N.A. 6- CHECK VALVE BYPASS TO PERMIT TO RAISE THE TEMPERATURE DURING START-UP AND ALSO MAINTAIN THE TEMPERATURE AND PRESSURE IN THE DRUM 9 HP STEAM DURING TEMPORARY SHUTDOWN OF VACCUM RESIDUE FLOW. 10 MP STEAM 8- TO BE INSTALLED AT THE HIGHEST POINT OF THE STEAM OUTLET PIPELINE. 10- CONTINUOUS BLOWDOWN. MANUAL BLOWDOWN VALVE TYPE. 11 LP STEAM 11- INTERMITENT BLOWDOWN SPRING LOADED RETURN VALVE. 12 HP CONDENSATE 13- FOR NOZZLES DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWINGS. 13 MP CONDENSATE 15- SILENCER INCLUDES ANTIBIRD MESH. 16- REMOVABLE SPOOL PIECE. 14 LP CONDENSATE 17- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS011-TRJR-480274. 15 BFW 18- GATE VALVE SHALL BE INSTALLED WITH STEM IN OR BELOW THE HORIZONTAL POSITION. 16 PLANT AIR 19- HIGH RANGEABILITY: FT-0054A LOW FLOW RANGE AND FT-0054B HIGH FLOW RANGE. 20- MECHANICAL LINK. 17 INSTRUMENT AIR 21- FOR VDU BYPASS. 18 N.A. 22- CONTROL VALVE CHANGES PENDING FROM COMPANY´S INSTRUCTION TO PROCEED.
0025
0025
ZHA 0025
ZLS 0025 O
ZHS 0025
ZV 0025 +
ZLS 0025 C
ATM
2"-BDH-011040005-101CS1P-P
1-1/2" 3"x1-1/2" 3/4" D
FC TSO
011-071 011-071 011-071 011-074 011-074
7
2"
6
2"-RWA-011040301-301CG0W-N 5 4 2
15
4718
3 2 1
OLW
1"
3"x1" 3/4" D
06
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
05
06-OCT-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT/ STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
RDP / MAC
JAL
00
11-DEC-09
IFD
IFD: ISSUED FOR DESIGN
VJS / JLM
RDP / MAC
JAL
PREPARED BY
CHECKED BY
DATE
UTILITIES IDENTIFICATION
011-071 011-071
8
2167
REV
011-073 011-072 011-073 011-071
9
3"x1"
1"
FC CL300
REF. DWG POS.
NOTE 5
2" CL300 10ø MIN. 4"x2" 4"x2"
2"-OLW-011040306-101CS1P-N
3"-BFW-011040301-101CS1P-H
+
3/4" D
0178
10
101CS1P 301CG0W
LV 0065 A 3"x1"
LP STEAM
ZLO
NC
60º VIEW FROM X
TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
3"x1"
1"-CHP-011054801-101SD0P-N
12"-LPS-011040001-101CS1P-H
INJECTION QUILL
ZLC
2" 2"
D
DE
FC CL300 NOTE 22
3/4" D
S
OPEN BY-PASS
IA
+
3"-BFW-011040302-101CS1P-P
2
+
LV 0065 A
4
CLOSED
ZYV 0025
45%-100% SPLIT RANGE
6
SPLIT RANGE
REMOVABLE ELBOW 3"
0065
0-45%
TI
B2 D1
MIN.
OLW
1"
7
5
LV
DETAIL "A"
8
SPLIT RANGE
ZHSR 0025
NOTE 5
9
ZC 0373
1800 mm
10
11
DESCRIPTION
19 N.A. 20 FUEL OIL 21 FUEL GAS 22 N.A. 23 N.A. 24 N.A. 25 CLOSED DRAIN 26 N.A. 27 L.P. NITROGEN 28 H.P. FLARE 29 L.P. FLARE 30 SOUR/ACID FLARE 31 PILOT GAS 32 AUX COOLING WATER FLO FLUSHING OIL AMD AMINE CLOSED DRAIN CND TURBINE CONDENSATE
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 STEAM DRUM
011-074 011-076 011-075 011-080 011-077 011-079 011-071
Item Tags : 011-D-0011
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
011-D-0013
011-Y-0008
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480105.pid
Discipline: PRO
SA-JER-DS011-TRJR-480105 2271-011-PID-0021-040
REV:
06
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
41
011-Y-0009 011-C-0003 LP STEAM SUPERHEATED SILENCER 1/2" 3/4" 12.00
39 38
ZC 0396
ZPZV 0019
39
0019
+
37
ZHXS
ZC 0321
ZHXS
ES
ZC 0372
ZHSR
34
3/4"
1"-IAI-011220311-301CG2P-N
8"-LPS-011041001-101CS1P-P
PIPING MFR. 31
101CS1P 101CJ1P
+
1"-IAI-011041301-301CG2P-N
17
30
S
MFR. PIPING.
8"x6"
ZYV 0019
DE
6388
PIPING INSTR.
ZV 0019 +
29
ATM
28
BY-PASS
OPEN
CLOSED
27
ZHA 0019
ZLO 0019
ZLC 0019
25
ZHS
ZLS
ZLS
0019
0019 O
0019 C
34
RESET
33 32
NOTE 4 RO 0014 TI 0181
ZC 0372
CLOSE STRIPPING STEAM
LL
ZC 0396
TI 0180
FC 0056
INST. PIPING
1/2"
2"
S
+
NOTE 10, 13
IA DE
L
CLOSED
OPEN
POSITIONER
BY-PASS
31
ZLC
ZLO
ZYC
0021
0021
0021
ZHA 0021
30
1"-OLW-011041302-101CS1P-N
29
ATM
FT 0056 TT 0181
ZYV 0021
011-Y-0010 FMC
ZC 0372
OLW
6"-LPS-011041008-101CJ1P-H
35
ZHSR
4"-LPS-011041004-101CS1P-H
1/2"
FV 0056 +
3/4"
ZC 0372
0021
D
26
ZC 0321
ZC 0321
+
FO TSO NOTE 17
ZC 0396 ZC 0396
NOTE 16 32
37 36
NOTE 10
1"-OLW-011041301-101CS1P-P
V
0019 A
0021
011-Y-0009
RESET
ZPI
33
38
ES
ZHXS
NOTE 8
0019
35
ES
0021 L
0019 L NOTE 8
36
40
ES
ZHXS
+
011-Y-0010 011-C-0003 VDU STRIPPING STEAM SILENCER
101CJ1P 101CS1P
40
16"
CL300 LPT 3/4" D
24
TI
TT
0206
0180
2"CL300 32"x16"
28
ZLS 0021 C
NC OLW
2"
ZLS 0021 O
ZY 0021
ZHS 0021
27
ZV 0021
26
+
32"-LPS-011041006-101CS1P-H
25
FC NOTE 3 3/4" D CL300
FC TSO NOTE 3
MIN.
24
23
23
16"x10" 10"
22
16"x10"
22
21
21
20
20
19
19
12" ST
18
18
NOTE 18 17
17
D 16
3/4"
D
3/4"
D
3/4"
16
3/4"
15
15
14
14
NC
13
13
12
12
11
11
OLW
10
9
9
32"-LPS-011041006-101CS1P-H
10
8 7 6 5
8 7 6 5
4
4
3
16"-LPS-011029004-101CJ1P-H
2 1
TO 011-C-0003
1
FROM 011-F-0002 DS011-TRJR-480079 3307
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1,2,5,6,7,9,11,12,14 DELETED. 3- VALVE TO BE LOCATED AT MINIMUM DISTANCE OF THE 011-C-0003 NOZZLE. 4- RO SIZED TO ENSURE MINIMUM FLOW THROUGH COIL AND PREVENT HIGH TEMPERATURE IN THE COIL AND DOWNSTREAM PIPING. 8- LOCAL EMERGENCY SWITCH BEHIND FIREWALL OR AT SAFE LOCATION. 10- SILENCER INCLUDES ANTIBIRD MESH.
Kg/hr barg °C barg °C
011-Y-0009 DIFFUSER+ABSORP. 3520.0 0.30 350.00 3.50 386.00
011-Y-0010 DIFFUSER+ABSORP. 1000.0 ATM NOTE15 350.00 3.50 386.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
2
DS011-TRJR-480081 3363
STRIPPING STEAM
SILENCER TYPE FLOW OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP.
3
STRIPPING STEAM
13- TO ATMOSPHERE AT SAFE LOCATION. 15- MAXIMUM OP. PRESSURE: 0.80barg 16- AIR VESSEL TO ALLOW 3 FULL STROKES CAPACITIES AND SHALL BE LOCATED OUTSIDE OF FIRE HAZARDOUS AREA.. 17- FIRE-PROOFING ACCORDING TO JERERMS-J-4717. 18- STRAINER INTEGRATED IN STEAM TRAP.
06
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
05
06-OCT-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MMG / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 STRIPPING STEAM INJECTION
011-074 011-076 Item Tags :
011-075 011-080
011-Y-0009
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
011-Y-0010
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480106 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480106 2271-011-PID-0021-041
REV: 06
Sheet: 1 of 1
SCALE: NONE Format:
A1
41
41
011-E-0032-A / B BRINE/DESALTING WATER EXCHANGERS
40
40
INSULATIONS (SHELL / TUBE): H / H TRIM: PRW-011042601-106CS2P/ BRN-011042601-103CS4P
39
39
6"-PRW-011042001-106CS2P-H
38
2"
37 36
TI
TT 0182
0182
0187
37
B4
35
TI 0183
011-E-0032-A
A4
B1
33
0187
38
6"
A1
34
TI
36
6"
35
TT
34 33
2" TT
32
32
0183 6"
6" CL300
31
CL600
31
LPT TW 0334
30
2"
TW 2"
2"CL600
6"-BRN-011042001-103CS4P-P
BRINE TO 011-A-0006
0335
30 4258
29
29
A2
B3
CL300
011-E-0032-B
A3
B2
27
1"-BRN-011042007-103CS4P-P MIN. 1"
6"
6"
MIN.
28
2"x1"
28
TI
27
0188
26
25
103CS4P 101CH2S
6"-BRN-011042001-103CS4P-P
24
2"-CLD-011042302-101CH2S-P
23
25
TT 0188
24 23
25
LPT
2"
5429
6"-PRW-011043007-106CS2P-H
22
250 mm MIN.
26
22
1-1/2" D
21
21
FC 0005
20
20
FT 0005
19 18
INST. PIPING 1/2"
1/2"
1/2"
1/2"
17
6"x4"
16
19 18
FV 0005
17
+
2" 4"x2"
4"x2"
4"-PRW-011042005-106CS2P-H
16
FC
15
3/4" D
3/4" D 14
14
FC 0060
13
4"x2"
FT 0060
12
INST. PIPING 1/2"
11
1/2"
10
4"x2"
13 12
1/2" 1/2"
11
FV 0060 +
10
4" 6"x4" 9
FC
FC 0004
8
2" NC
6"x4" 9
15
3/4" D
3/4" D
8
7 6
INST. PIPING 1/2"
1/2"
1/2"
1/2"
FV 0004 +
5
6"x3"
4
6"x2"
2"
6"-PRW-011043007-106CS2P-H
FT 0004 6"x2"
NC
3" 6"x3" FC
3/4" D
3
3/4" D
6 5 4 3
DESALTING WATER
2
6"x2"
DS011-TRJR-480110 3489
4"-PRW-011042005-106CS2P-H
NC
6"-BRN-011006001-103CS4P-P
2"
DESALTING WATER TO 011-D-0001
DESALTING WATER TO 011-D-0002
DESALTER BRINE FROM 011-D-0001
DESALTING WATER TO 011-E-0001
DS011-TRJR-480010 2923
DS011-TRJR-480013 2942
DS011-TRJR-480010 2924
DS011-TRJR-480003 2697
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001).
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-E-0032-A / B AES 38.80 12.00 57.40 150.00 115.00 86.80 49.80 38.30 165.00 180.00 341.0 NOTE 3 6.71 NOTE 4
NOTE 5
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
POS.
1 2 3 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 5 6 NOTES 7 1,2 DELETED 8 3- SURFACE AREA (m2) : TOTAL (2 SHELLS) : 341,0 m2, FOR SHELL: 170.6 m2. 9 4- TOTAL DUTY (2 SHELLS). 10 5- HV@150ºC (SHELL AND TUBE SIDE) 11 12 13 14 15 16 17 18
2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
05
13-MAR-2013
AB
04
30-SEP-2011
03
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MRM / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JVM / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JVM / JLM
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION
GENERAL NOTES
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
2
FROM 011-E-0024
6"-PRW-011042006-106CS2P-H
6"-PRW-011042002-106CS2P-H
6"x2" 1
7
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-078 011-075 011-080
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 BRINE-DESALTING WATER EXCHANGERS ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480107.pid
Discipline: PRO
SA-JER-DS011-TRJR-480107 2271-011-PID-0021-042
REV:
05
Sheet: 1 of 3
SCALE: NONE Format:
A1
41
41
011-A-0006-A/B BRINE COOLER
40
40
39
39
38
38
37
37
36
36
35
35
34
34
33
33
32
32
31
31
30
6"-BRN-011042001-103CS4P-P
BRINE
30
4258FROM 011-E-0032 A/B
1"
29
6"x4"
UC
29
6"x4" 28
28
4"
27
4"
27 26
26 25
4"
24
25
NOTE 5 1%
4"
N1 N2
1-1/2"
4"
CL300
22
N4
N4
D
1-1/2"
23
NOTES 4,6
N2 4"
24
011-A-0006-A/B
N1
23
CL300
22
D
21
21
M
20 19
M
20 19
4"
18
4" TYP. 7
TYP. 7
MCC
17
MCC
18
ZC 0414
17
16
16
15 14
MA
MA
0006 A
0006 B
NOTE 7
NOTE 7
15 14
TI 0186
13
6"x4"
13
6"x4" 12
12
TT 0186
11 10
11 10
2" CL300
6"-BRN-011042002-101CS4P-P
9
BRINE TO 011-E-0033 4261
9
8
8
7
7
101CS4P 101CS1P
1-1/2"-BRN-011042008-101CS4P-P 6
2"x1-1/2" 5
6 5
1"-OLW-011042302-101CS1P-N 101CS4P 101CH2S
4 3
NC
4 3
2"-CLD-011042303-101CH2S-N
2
2
OLW
1
1 25 6911
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 2, 3 DELETED. 1- OP. TEMP. ºC IN / OUT: 116.1 / 65 4- AIR COOLER HAS 1 BAY WITH 2 MOTOR / FAN EACH AND 2 BUNDLES PER BAY. 5- 1% SLOPE IN LAST PASS OF TUBE BUNDLE HAS TO BE CONSIDERED. 6- SHUTDOWN PROTECTION DEVICES 2 ACCELEROMETERS SHALL BE PROVIDED. 7- VIBRATION TRIP IS REQUIRED FOR EACH MOTOR AS PER MOTOR TYPICAL. AIRFINS TYPE SURFACE OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP DUTY
m² barg °C barg °C Gcal/h
011-A-0006-A/B FORCED 353.0 10.20 116.10 16.00 145.00 5.28
NOTE 1
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JVM / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
VJS / FCB
RDP/ MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-078 011-075 011-080
Item Tags :
011-A-0006
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 BRINE COOLER ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480108.pid
Discipline: PRO
SA-JER-DS011-TRJR-480108 2270-011-PID-0021-042
REV:
05
Sheet: 2 of 3
SCALE: NONE Format:
A1
41
41
011-E-0033 BRINE TRIM COOLER
40
40
INSULATION (SHELL / TUBE): N / P
39
39
38
38
37
37
36
36
35
35
34
1"D2" 12.40
34
33
TZV 0006
33
+
+
2"-CWR-011042001-101CS1P-N
32
6"-BRN-011042002-101CS4P-P 31
2"x1"
32
CL300 2"-CWR-011042002-101CS1P-N
31
3/4" 30
30
D
MIN.
28 27
TI 0184
26
2" CL300
25
FB LO
29
NOTE 3
2"-CWR-011042301-101CS1P-N
NOTE 6
29
28 27 26 25
24
24
23
23
6"
22
12" A2
B1
21
21
011-E-0033
A1
B2
12"
6"
20
12"-CWR-011042301-101CS1P-N
20
22
19
17 16 15 14 13
LPT
MIN.
12
MIN. 11
H
TI 0185
10 9
BRINE FROM 011-A-0006 4261
3/4"
3/4"
D
D
12 11 10 9
3 4716
SC
8
13
101CS1P AG 301FE0W UG
12"-CWR-011072303-301FE0W-N
NOTE 4 TYPE 1
16
14
2" CL300
6"-BRN-011042002-101CS4P-P
17
15
TT 0185
18
MIN.
6"-BRN-011042003-101CS4P-N
12"-CWS-011042301-101CS1P-N
18
19
8
3
011-SC-0005
4715
7
1"
6 5
FI 0057
1-1/2"-BRN-011042006-101CS4P-N
FT 0057
1"-OLW-011042301-101CS1P-N 2"x1-1/2"
2
1/2"
4 3 2
6"-BRN-011042003-101CS4P-N
MIN.
5
CL300
101CS4P 101CH2S
1
6
101CS4P 101CS1P
MIN.
4 3
7
1"-BRN-011042004-101CS4P-N INST. PIPING 1/2"
OLW
2"-CLD-011042301-101CH2S-P
25 2828
1
BRINE TO B.L. DS011-TRJR-480132 3490
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1,2 DELETED. 3- AT GRADE AT SAFE LOCATION. 4- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS011-TRJR-480273. 5- H.V. @ 150ºC (SHELL AND TUBE SIDE. 6- BLOCK VALVE SHALL BE INSTALLED WITH THE STEM IN OR BELOW THE HORIZONTAL POSITION AS REQUIRED.
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-E-0033 AES 6.00 9.80 36.50 65.00 41.50 41.50 12.40 16.00 80.00 116.00 351.1 2.45
NOTE 5
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JVM / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
ISSUE FOR COMPANY REVIEW
JVM / JLM
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 BRINE TRIM COOLER
011-074 011-078 Item Tags :
011-075 011-080
011-E-0033
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480109.pid
Discipline: PRO
SA-JER-DS011-TRJR-480109 2271-011-PID-0021-042
REV:
05
Sheet: 3 of 3
SCALE: NONE Format:
A1
41
41
011-E-0024 LAGO/DESALTING WATER EXCHANGER
40
40
INSULATION ( SHELL / TUBE ): P / P 39
39
38
38
37
37
36
36
35
35
34
34
33
33
32
32
31
31
6"-PRW-011043007-106CS2P-H
30
30
29
29
28
28
6"-DIE-011004001-103CS1P-H
27
27
26
6" 25
8"
B1
A2
24
25
TI
011-E-0024
0190 24
B2
A1
8"
6"
23
26
8"x6"
23
011-SC-0014 8"x6"
22
SC 3/4"-PRW-011043012-106CS2P-N
21
DV TYPE 1 NOTE 5
TT 0190
22 21
2"
PROCESS WATER FROM 011-G-0021 A/B4265
6"-PRW-011043006-106CS2P-P
20
3/4" D
19
20 19
18
18
17
17
16
16
15
15
14
14
13
13
12
12
11
11
10
10
MIN.
LPT
9
9
8
8
7
7
3/4"-DIE-011043002-103CS1P-P TI 0189
6
TT 0189
2"
MIN.
6
3/4"
2"x3/4"
5
5
4
4
103CS1P 101CH2S
3
3
2"-CLD-011043301-101CH2S-P
DESALTING WATER
6"-DIE-011043001-103CS1P-P
1
6"-DIE-011004001-103CS1P-H
2
6"-PRW-011043007-106CS2P-H
2
IN/OUT IN/OUT
NOTE 6
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
MJR / STG
AB: AS BUILT
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
MRM / STG
RDP / MAC
JAL
IRG / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
TO 011-A-0003
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
DS011-TRJR-480007 2851
DS011-TRJR-480059 3269
REV
DATE
UTILITIES IDENTIFICATION 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
JAL
04
AFC: APPROVED FOR CONSTRUCTION
POS.
AVS / HCR
03
AFC
1,2,3,4 DELETED. 5- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS101-TRJR-480273. 6- H.V.@ 150ºC. SHELL AND TUBE SIDE.
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
AB
17-JUN-2010
NOTES
SHELL/TUBE SHELL/TUBE
13-MAR-2013
01
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED.
011-E-0024 AES 13.80 39.60 109.00 43.00 85.50 57.40 38.30 49.80 135.00 150.00 81.3 1.65
05
LAGO
GENERAL NOTES
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
1
LAGO FROM 011-E-0006
TO 011-E-0032 DS011-TRJR-480107 3489
25 5417
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 DESALTING WATER SURGE DRUM
011-074 011-076 Item Tags :
011-075 011-080
011-E-0024
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480110.pid
Discipline: PRO
SA-JER-DS011-TRJR-480110 2271-011-PID-0021-043
REV:
05
Sheet: 1 of 3
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
37
36
36
35
35
34
34
33
33
32
32
31
31
30
30
H AI L 0018 A
ZC
29
0398
29
28
28
AT
SAMPLE LINE
27
0018 FI 0180 B
26
RETURN SAMPLE LINE
27
PH NOTE 5
26
LL
2" CL 600
25 24
INST. PIPING
25 24
FT 0180 B
23
INST. PIPING
INST. PIPING 1/2"
22
1/2"
23
3/4" 2"
22
21 20
21 4265
PROCESS WATER TO 011-E-0024
6"-PRW-011043006-106CS2P-P
20
2"
19
19
2"-PRW-011043019-103CS2P-P
18
PIPING 1/2" INST.
17
1/2"
PROCESS WATER FROM 011-D-0007 4266
8"-PRW-011043003-101CS2P-P
18 17
FT 8"-PRW-011043003-101CS2P-P
0180 A 101CS2P 106CS2P
011-G-0021-B
INST.
8 7
3/4" 3/4"
PI
6"x3"
0096
6
NOTE 6
INST.
NOTE 2
DS011-TRJR-480244 10788
3/4"
5
M
11 10 9 8
3/4" 7
LPT
3"
6
6" 8"x6" NOTE 1
INST. PIPING
M
5
NOTE 5
3/4" 3
NOTE 6 6"x3"
NOTE 5
4
011-G-0021-A
0097
6" 8"x6" NOTE 1
PIPING
PI 0263
3/4" 3/4"
PI
LPT
3"
MIN.
MIN.
3/4"-PRW-011043004-106CS2P-P
12
8"-PRW-011043004-106CS2P-P
DS011-TRJR-480244 10787
TO OLW
13
MIN.
3/4"-PRW-011043005-106CS2P-P
WATER
3/4"
UC
PIPING
TO OLW
9
PI 0286
MIN.
INST.
WATER
8"-PRW-011043005-106CS2P-P
10
NOTE 2
15 14
MIN.
11
UC
3/4"
INST.
12
PIPING
L
13
LPT
NOTE 3
LPT
PIPING
0180 A
MIN.
1-1/2"-PRW-011043015-106CS2P-P
FI
14
16
101CS2P 106CS2P
PIPING
NOTE 3
1-1/2"-PRW-011043014-106CS2P-P
15
INST.
16
3/4"
4
3/4"
NOTE 3
1-1/2"-PRW-011043015-106CS2P-P
3/4"
NOTE 3
3
1-1/2"-PRW-011043014-106CS2P-P
2
2
MCC
1
NC
106CS2P 101CS1P
TYP. 3
ZC 0398
ZC 0319
MCC
OLW
ZC
0398
0319
1
ZC
ZC 0397
106CS2P 101CS1P
MG 0021 B
1-1/2"-OLW-011043303-101CS1P-N
ZC
NC
MG 0021 A
1-1/2"-OLW-011043304-101CS1P-N
011-G-0021-A / B DESALTING WATER PUMPS
0397
TYP. 3
OLW
INSULATION: N
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 4 DELETED 1- PROVIDE A STRAIGTH LENGTH OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 2- CHECK VALVE SHALL BE INSTALLED HORIZONTALLY. 3- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 5- LOCATED IN SELF STANDING RACK. 6- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JER-DS011-TRJR-480244.
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
m³/h barg bar barg °C kg/m³
011-G-0021-A / B CENTRIFUGAL 116.0 37.70 35.49 49.80 43.00 991.0
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MRM / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / FBL
RDP / MAC
JAL
00
11-DEC-09
IFD
IFD: ISSUED FOR DESIGN
IRG / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 DESALTING WATER PUMPS
011-074 011-076 Item Tags :
011-075 011-080
ORIGINAL SIGNED IN PROJECT FILE
011-G-0021 A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480111.pid
Discipline: PRO
SA-JER-DS011-TRJR-480111 2271-011-PID-0021-043
REV:
05
Sheet: 2 of 3
SCALE: NONE Format:
A1
41
FI 0059
40
41
011-D-0007 DESALTING WATER SURGE DRUM
40
TRIM: PRW-011043601-101CS1P / PRW-011043602-103CS1P / PRW-011043603-103CS2P INSULATION: P
39
39
38
38
FY 0059
37
6"R8" 2.75
55-100% 101CH2F 101CS1P
PV 0311 B +
35
3"x2"
3"-LFL-011043301-101CH2F-N
29
34
2"
2138
3/4" D 33
FC 03 TSO CL300
SPLIT RANGE
PY
2"-PRW-011043001-101CS1P-N
NOTE 8, 9
3/4"
PZV 0049
3/4" D
L
PT
0-45% 30
PC 0311
0231 PV 0311 A
INST. PIPING
+
3/4"
28
PT
2"
2"-N2L-011043301-101CS1P-N
27
27
6244
3/4" 26
D
FC TSO CL300
3/4"
D 2"
FC 0059 A
24
FT 0059 A
23 22
1/2"
1/2"
2"
NC
INST. PIPING
15
3/4"
P1
33
PZV 0050
3/4" 12"x8"
+
101CS1P 101CH2F
NOTE 4
3/4" 3/4" NOTE 7
011-SP-0035
FB LC NOTE 4
32
29
FB LO
CL300
12"x6"
12"-LFL-011043302-101CH2F-N
V
101CS1P 101CH2F
31
10789
30 29 28
LY
4"
3/4"
FC CL300
D
6"x4"
26 25
FC
INST. PI
0059 B
0310
FT
SPLIT RANGE
24
0059 B
1/2"
FV 0059 B
23
INST. PIPING
1/2"
22
+
21
3" 6"x3"
6"x3"
6" A1
6"-BFW-011043301-101CS1P-H MIN.
3/4"
27
0067 B
NOTE 6
6"x4"
6"-BFW-011043301-101CS1P-H CL300
E
+
011-D-0007
FV 0059 A
21
4699
6" PIPING 10" W V 2" P2 2"
34
55-100%
+
20
INST. PIPING
2"
1-1/2"x1" 1" 1-1/2"x1"
25
6"R8" 2.75
FB LO NOTE 4
0311
35
29
NOTE 8, 9
12"x10"
29
NOTE 5
0.2 %
12"-LFL-011043303-101CH2F-N
2137
3/4" PI 0231
36
NOTE 4 LO FB
CL300
12"x6"
NC
31
V
12"x8"
+
0311
2"x1-1/2"1-1/2" 2"x1-1/2"
32
+
12"-PRW-011043002-101CS1P-N
36
3/4"-LFL-011043302-101CH2F-N
37
A2
FC CL300
6" 3/4"
D
D
20
CL300 3/4"
D
19
19
17
PROCESS WATER TO 011-G-0021 A/B
INST.
6"x3"
PIPING 2"
NOTE 1
CSC NC LI
16
0069
H
LT
1/4"
D
L
12 11
2"
2" L1B
2" 1/4" D
8"-PRW-011043003-101CS2P-P
13
L2B
0069
15 14
L3A
2"-PRW-011043018-101CS2P-P
3/4"
PIPING 2" 2"
L3B
2" L1A
2"
V 2" MIN.
1/4"
D 1/4"
MAG
LG 0068
LT
LC
0067
0067
15 14
NOTE 1
2"
8"
3/4"
NC
D1
D
NC
101CS2P 101CS1P 2"-OLW-011043301-101CS1P-N
4 3 2 1
101CS2P 101CS1P
6"x3"
10
FV 0171
NC
6"x3"
6"x3"
+
9
3"
3/4" D
INST.
PIPING 1/2"
FT 0171
DS011-TRJR-480132 3534
PHENOLIC STRIPPED SOUR WATER FROM B.L. DS011-TRJR-480135 3533
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES
DRUM TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
mm mm barg °C barg °C
011-D-0007 VERTICAL 4800.0 1900.0 1.00 50.00 3.50 150.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
2, DELETED. 1- ENSURE THAT NOZZLES FOR LEVEL TRANSMITTERS ARE AT THE SAME ELEVATION. 3- THE LINE EXIST: FOR UNIT 011 AND NOT FOR UNIT 012. 4- BLOCK VALVE SHALL BE INSTALLED WITH THE STEM IN OR BELOW THE HORIZONTAL POSITION AS REQUIRED BY API 520 PART II SECTION 6. 5- MAKE CONNECTION ON TOP OF PIPE. 6- FOR NOZZLES DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING. 7- MECHANICAL LINK. 8- SET PRESSURE READJUSTED BASED ON DISTANCE FROM UPPER TL OF D-0007 TO PZV, ELEVATION DIFFERENCE SHOULD NOT BE HIGHER THAN 8.7m. 9- PZV-0049 / 0050 SIZE HAVE BEEN CALCULATED TAKING INTO ACCOUNT Cv RATED OF FV-0059 A (Cv-69), FV-0059 B (Cv-117), FV-0171 (Cv-117). 10- IN CASE OF D-0007 HIGH LEVEL (LAH-0067), FC-0171 WILL BE FORCED TO MANUAL MODE AND OUTPUT TO 0% (FMC) TO AVOID D-0007 OVER FILLING.
05
13-MAR-2013
AB
04
30-SEP-2011
03
FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
SIGNAL FROM B.L
2
DS011-TRJR-480132 3794
1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MSS / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JGT / STG
RDP / MAC
JAL
REV
DATE
UTILITIES IDENTIFICATION 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
5
3
OLW
DESCRIPTION
6
1/2" NON PHENOLIC STRIPPED WATER FROM B.L.
POS.
7
4
OLW
GENERAL NOTES
8
CL300
6"-STW-011098002-101CS2P-N
2"-PRW-011043017-101CS2P-P
FC CL300
0171
2"-PRW-011043008-101CS2P-P
MIN.
8"-PRW-011043003-101CS2P-P
3"
2"-OLW-011043302-101CS1P-N
LPT
11
6"x3"
FC
8
12
3/4"
9
2"
16
0-45%
13
B1
2"
5
17
SPLIT RANGE
NOTE 10 FMC
6
18
6"x3"
NC
10
7
3"
6"x3"
0067
2"
L2A
S
UC
LY
NC
3/4"
2" 24"D MH 2"
M1
INST.
NOTE 3
4266
3"
6"-STW-011098001-101CS2P-N
6"x3"
4500
18
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 DESALTING WATER SURGE DRUM
011-074 011-076 Item Tags :
011-075 011-080
011-D-007
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480112 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480112 2271-011-PID-0021-043
REV: 05
Sheet: 3 of 3
SCALE: NONE Format:
A1
41
41
011-D-0006 SOUR WATER RECOVERY DRUM
40
40
TRIM: NAP-011044601-101CH2S / AWS-011044601-103CH2S INSULATION: P
39
39
4"-NAP-011019004-101CH2S-P
38
38
37
37
4"-AWS-011021001-101CH2S-N 36
36
35
35
6"-AWS-011019001-101CH2S-P
34
34
33
33
32
32
31
31
LC
30
0080
H
SIGNAL TO 011-LV-0080 4273
L
29
29
HPT 3/4"-LFL-011044301-101CH2F-N
29
28
28
5012
101CH2F 101CH2S
27
30
NOTE 3 27
3/4"
NC 26
3/4"
25
MIN.
26
H
LI 0100
3/4"-AWS-011044013-101CH2S-P
25
24
24
PIPING INSTR.
23
PI 0320
GVR LT
0346
4"
6"
V
4"
2"
A1
E
A2
2"
20
2" L1B INST.
19
2"
NOTE 1 LI 0107
LL
MAG
LT
LT
LG
0107
0080
0079
3"
3"
D2
17
NOTE 1
16
3/4" UC
15
2"-AWS-011044014-101CH2S-P
S
NO POCKET
MIN.
12
D
21
P1 20
PIPING 1/4" 1/4" 2" 1/4"
19
1/4" L3B
18
MH 24"
M1
2"
17
L3A
16 15
B1
6"
2"-AWS-011044012-101CH2S-P 101CH2S 101CS1P
14
011-D-0006 NOTE 5
13 12
11
3/4"
NOTE 2
10
L2A 2"
2" 2"
L4
V1
22
L1A
D1
2"
13
INST.
2"
L2B 1/4" PIPING 2" 2"
1/4" 2"
V
2" 14
INSTR. PIPING
4"
PUMP STOP
18
NOTE 6
5950 mm
21
0100
MIN.
ZC
22
23
NC
INST. PIPING
2"-OLW-011044304-101CS1P-N
11 10
OLW
9
3/4"-AWS-011044005-101CH2S-P
9 8 7 6 5
8
6"-AWS-011044001-101CH2S-P
SOUR WATER TO 011-G-0006 A/B
7 4284
6 5
3
1
NAPHTHA
SOUR WATER
SOUR WATER
3"-AWS-011044017-101CH2S-P
4"-NAP-011019004-101CH2S-P
2
6"-AWS-011019001-101CH2S-P
3
2"-AWS-011012001-101CH2S-P
4
4"-AWS-011021001-101CH2S-N
4
FROM 011-D-0005
FROM 011-D-0003
FROM 011-D-0004
DS011-TRJR-480046 3283
DS011-TRJR-480050 3255
DS011-TRJR-480023 3155
DS011-TRJR-480046 3284
1
SOUR WATER 011-D-0004 DS011-TRJR-480046
SOUR WATER
FROM/TO 011-D-0004
2
8258
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1- ENSURE THAT NOZZLES FOR LEVEL TRANSMITTERS ARE AT THE SAME ELEVATION. 2- EQUILIBRIUM LINE. 3- MAKE CONNECTION ON TOP OF THE LINE. 4- DELETED. 5- FOR NOZZLES DETAILS ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING. 6- INTERFACE LEVEL TRANSMITTER. DRUM TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
mm mm barg °C barg °C
011-D-0006 HORIZONTAL 3900.0 1500.0 0.30 62.00 5.00 110.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JGT / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 SOUR WATER RECOVERY DRUM
011-074 011-076 011-075 011-080
Item Tags :
011-D-0006
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480113 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480113 2271-011-PID-0021-044
REV: 05
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
37
36
36
35
35
34
34
33
33
SIGNAL
FROM LC-0080 32 4273
32
FI
31
0115
TI 0368
31
FT
30
30
0115 29
1/2"
1/2"
1/2"
1/2"
INST. PIPING
28
29
TT 28
0368 LV 0080
27
27
+
2" 26
6"x3"
6"-AWS-011044002-106CH2S-P
6"x3"
3"
26
FC
6"-AWS-011044001-101CH2S-P
23
6"-AWS-011044001-101CH2S-P 22
101CH2S
21
101CH2S
3/4"
D
3/4" D
3/4"
3/4" 4"x3"
3"
4"x3"
NC
20
24 23 22 21 20
SC
106CH2S LPT
3/4"
UC
17
18
NOTE 3
2"x3/4"
UC MIN.
MIN.
17
8"x6"
6"-AWS-011044015-106CH2S-P 106CH2S 101CH2S
15
2"-CLD-011044304-101CH2S-N
6"-AWS-011044001-101CH2S-P
6
011-G-0006-A
6"x2" NOTE 6
3/4"
13 12
PI 0190
INST.
3/4" 3/4"
PI 0124 3/4"
PIPING
011-G-0006-B 6"x2"
LPT NOTE 1 6"x3"
M
1-1/2"
NOTE 6 3/4"
11 10
M
1-1/2" 1"x3/4"
1-1/2"-AWS-011044008-106CH2S-P
1-1/2"-AWS-011044009-106CH2S-P
4
MIN.
MIN.
TYP. 3 106CH2S 101CH2S
MG 0006 A
250mm MIN.
1
NOTE 9 2"-OLW-011044305-101CS1P-N
3/4"-OLW-011044302-101CS1P-N TYP. 3
OLW
106CH2S 101CH2S
MG 0006 B NOTE 9
OLW
2"-CLD-011044302-101CH2S-N
2"-CLD-011044302-101CH2S-N
2"x1-1/2"
250mm MIN.
2"x1-1/2"
MCC
0346
3/4"-OLW-011044303-101CS1P-N
106CH2S 101CS1P
MCC 106CH2S 101CS1P
0346
2
NOTE 4
ZC
MIN.
NOTE 4
ZC
MIN.
3
2"-CLD-011044303-101CH2S-N
011-G-0006-A / B CDU SOUR WATER PUMPS
3076
OLW
25 3077
INSULATION: P
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
m³/h barg bar barg °C kg/m³
011-G-0006-A / B CENTRIFUGAL 48.0 9.20 7.59 54.70 62.00 980.0
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
1- PROVIDE A STRAIGTH LENGTH OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. 2- CHECK VALVE SHALL BE INSTALLED HORIZONTALLY. 3- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 4- DISMONTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION. 5- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-05011-TRJR-480275 6- FOR INSTRUMENT DETAIL SEE VENDOR DRAWING SA-JER-DS011-DSAZ-480001 7- FOR VDU BYPASS. 8- FOR FURTHER INFORMATION SEE PUMPS AUXILARY DETAILS DIAGRAM SA-JER-DS011-TRJR-480272. 9- COUPLING HOUSING DRAIN.
05
13-MAR-2013
AB
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
7 6 5 4 3
SOUR WATER
SOUR WATER
FROM 011-G-0019
TO B.L.
DS011-TRJR-480088 3432
DS011-TRJR-480132 3535
2 1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MMG / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS.
8
OLW
2"-OLW-011044306-101CS1P-N
25
NOTE 7
D
5
1"x3/4"
9
3/4"
6"-AWS-011033002-106CH2S-N
LPT NOTE 1 6"x3" MIN.
SOUR WATER 4284FROM 011-D-0006
3/4"
6773
PIPING 1/2"
MIN.
8
PIPING 3/4" 3/4"
PI 0123
PIPING
9
INST.
INST.
INST.
10
PI 0187
PIPING 1/2"
PIPING
11
6"-AWS-011044004-106CH2S-P
12
INST.
14
25
NOTE 2
1-1/2"-AWS-011044008-106CH2S-P
13
INST.
6"-AWS-011044003-106CH2S-P
NOTE 2
15
1-1/2"-AWS-011044009-106CH2S-P
14
16
250mm MIN.
16
8"-AWS-011044002-106CH2S-P
NOTE 3
19
MIN.
3/4"
MIN.
LPT
MIN.
106CH2S
18
3/4"-AWS-011044016-106CH2S-P MIN. 3/4"
011-SC-0004 TYPE 23 NOTE 5
19
7
25
3/4"-AWS-011044011-106CH2S-P
24
3/4"-AWS-011044010-106CH2S-P
25
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CDU SOUR WATER PUMPS
011-074 011-076 Item Tags :
011-075 011-080
011-G-0006-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480114.pid
Discipline: PRO
SA-JER-DS011-TRJR-480114 2271-011-PID-0021-044
REV:
05
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
41
0005AL THRU 0005JL
BHS 0005
40
IGNITION PERMISIVE 0005A THRU BXS 0005J NOTE 27 0005
39 38
BY
. AIR/FUEL RATIO SYSTEM ZC 0331
35 34
BS 0001 0001A THRU 0001J
ZC 0330
32
UC 0330
L LL A.R./FUEL RATIO
MIN FIRING CONDT.
31
ZC
FFI 0190
BLL 0001
NOTE 4
OFF
3/4"
HH
ZC
PI
PT
0330
0331
0132
0132
25
PI 0138
24
20
ZHS 0032
19
ZLO
ZLC
ZC
ZHA
0032
0032
0331
0033
ZLS 0032 O
ZLS 0032 C
ZYV 0032 +
OPEN
BY-PASS
ZC
ZC
0331
0333
CLOSED
ZLO 0033
ZLC 0033
ZYV 0033
3/4"
NOTE 3 BY-PASS
L 3/4"
ZHS 0033
S
ZLS
0033 O
0033 C
ZV 0033
S
0035 FC TSO
IA
2"-FGS-011045002-101CS2P-N
3/4"
ZLO
ZLC
ZC
0036
0036
0036
0036
0330
TO ATM NOTE 12
S
ZHS
ZY
ZLS
ZLS
0036
0036
0036 O
0036 C
PIPING INST.
10
CLOSED
ZHA 0042
ZLO
ZLC
0034
0034
+
9
ZHS 8
0034
ZLS 0034 O
ZLS 0034 C
HH
ZC
2"x1" D
NOTE 21
S
PCV 0141
1"
+
ATM 7
CL300 FC NOTE 28 2"x1" 3/4"
ZV 0036
+
HIXS 0044 L
ES
ZC 0331
ZC 0330
ZC 0330
24
PB
HISR 0044
+
FC TSO
PB
HISR 0045
NOTE 8
RESET
21
RESET
20 19
ZV 0035
HH
3/4"
+
ZC 0330
CLOSED
POSITIONER OPEN
BY-PASS ZHA 0037
ZYC 0037
ZLO 0037
ZC 0320
PT 0386
PI 0386
ZC
START-UP LOCAL PANEL (011-LP-F-0001) NOTE 16
LL
NOTE 27
NOTE 3
NOTE 21
PCV 0389
HS
HXS
0050 BL
0097 AL
HS 0050 AL
HS 0051 L
HSR 0052 AL
HSR 0053 AL
HS 0054 L
HSR 0052 BL
HIXS 0045 BL
HIXS 0044 BL
17 16
HSR 0053 BL
ZC 0331
ZV 0037
ZC 0332
+
ZYV 0037
ZC 0331
ZHS
ZY
ZLS
ZLS
0037
0037
0037 O
0037 C
DE
COMMON ALARM
1"
CL300 FC NOTE 28
PC
NOTE 29
NOTE 27
RESET MIN HXS FIRING CELL B 0097 BL
3/4"
12 11
XL 0061 AL
XL 0061 BL
10
READY BURNERS GAS LINE CELL B
9
INST. PIPING ZC 0332
FY 0069
5
0050 L
PV
D
ZC
0136 A L
FC 0069
2"x1" 3/4"
+
H
PT 0136
13
READY BURNERS GAS LINE CELL A
UA
SP START UP
ATM
14
ZC 0330
TSO
+
S
2"x1" D
3/4"
ZC 0331
ZC 0320
ZC 0330
PY 0136
OP
MASSFLOW
3/4"
PC 0136 B SP.MIN.
FI 0069
FLC 6" CL300
PV 0136 +
3/4"
8
3" 3/4"
UA
XL
XA
XL
XL
XL
XL
XL
XA
XL
D
0051 L
0052 AL
0053 AL
0054 L
0055 L
0056 L
0057 L
0058 L
0059 L
0060 L
FORCED FAN RUNNING
INDUCED FAN RUNNING
READY TO START PURGE
PURGE TRIPPED
READY PILOT GAS LINE
3/4" D
D
LEAK TEST LEAK TEST FAULT OK A CELL A
COMMON TRIP
FLC 2" NOTE 25 CL300
INST. PIPING
PURGE PURGE IN COMPLETED PROGRESS
XL
XL
XL
XL
XL
XL
XL
XL
0052 BL
0053 BL
0050 AL
0050 BL
0050 CL
0050 DL
0097 AL
0097 BL
LEAK TEST OK B
LEAK TEST FAULT CELL B
READY FOR LEAK TEST ON CELL A
READY TO RESET MIN FIRING CELL A
READY TO RESET MIN FIRINC CELL B
3"
INST. PIPING
UC 0331
3/4"
3/4"
1/2"
NOTE 6
2
INST. PIPING
D
FT 0069
3/4"
3/4"
INST. PIPING
+
0143
PDT 0143
PDT 0142
FV 0069
H
PDI
NOTE 29
4
18
RESET RESET PILOT BURNERS RESET PILOT RESET BURNERS START LEAK RESET MIN START LEAK GAS LINE START GAS LINE LAMP HEATER BURNERS GAS LINE GAS LINE TEST FIRING TEST CELL B CELL A CELL B PURGE CELL A TEST SHUT DOWN SHUT DOWN CELL B CELL A CELL A
FC
ZLC 0037
FMC
1
NOTE 11
NOTE 5
MIN.
3/4"
D
INST. PIPING 6
H
D
DE
LL
3/4"
DE
PDI 0142
26
IA
IA
3
8"-FGS-011045302-101CS2P-S
27
15
PI 0443
ZC 0331 ZYV 0034
2"
ES
HIXS 0045 A
PARTIAL S/D ( BURNERS)
DE
0333 OPEN
2"
ES
HIXS 0044 A
TOTAL HEATER S/D
3/4"
ZYV 0036
IA
NOTE 27
FC TSO
ZC
BY-PASS
28
25
PT 0443
+
14
11
29
23
IA
2"x3/4"
ZV 0034
12
2"
NOTE 5
FO TSO
FO TSO
13
ZYC
S
+
MIN.
3/4"-PTG-011045001-101CS1P-N
15
ZYV 0035
ATM
+
17
CLOSED
0131
ZHA
0126
NOTE 20
30
ATM
ZV 0032
16
ZLS 0035 C
MIN.
DE
TO ATM NOTE 12
ZLS 0035 O
ZHS
ATM
18
ZC 0330
0320
0126A THRU NOTE 20 0126J
PI
22
IA ZLS
ZLC 0035
BY-PASS POSITIONER OPEN
PT
RESET 31
3/4"
0125A THRU 0125J
PI 0125
3/4"
ZC
32
3/4"
PI 0130
0331
PB
HISR 0048
D
3/4"
INST. PIPING
ZC
ZC 0320
CLOSED
ZLO 0035
ZHA 0035
+
+
OPEN
LL
0332
ZC 0331
H
PT 0138
ZC
33
MIN.
21
0333
CLOSED
ZC 0332
UC 0330
8"x6"
ZHA 0032
OPEN
0330
PI 0131
8"x6"
BY-PASS 22
0330
NOTE 4 MIN. FIRING COND.3/4" V
HH
ZC 0330
34
PIPING INST.
3"x2"
ZC
23
ON
3"x2"
LL
ZC
35
ZC 0335
NOTE 11
NOTE 19
NOTE 19 PIPING INST.
PIPING INST.
ZC
ZC
1/2"
26
3/4"
3/4"
NOTE 24
3/4"
2" MTE
ZC 0331
3/4"x1/2"
BLH 0001
3/4"
36
3/4"
2"-PTG-011045301-101CS1P-S
0129 27
0001AL THRU 0001JL
C1
3/4"
INST. PIPING PI
1/2" FTE
C2
37
ES HIXS 0048 L
NOTE 8
PILOT FLAME DETECTOR (FOR EACH PILOT)
V
3/4"
28
NOTES 15, 26
BY VENDOR
0001AL THRU 0001JL
30 29
011-F-0001
BY VENDOR
0330
TOTAL HEATER F-0001 / F-0002 AND K-0002 A/B/C AND K-0003
0048 A
BE 0001
NOTE 23 33
ES
HIXS
NOTE 26
BA 0001
0001A THRU 0001J
38
0005A THRU 0005J
0005
3oo10
39
IGNITOR (FOR EACH PILOT)
37 36
40
UC 0331
READY FOR LEAK TEST LEAK TEST ON LEAK TEST IN PROGRESS PROGRESS ON CELL B CELL A CELL B
7 6 5 4 3 2 1
CL300
3/4"
SIGNAL FROM FY-0074-A
SIGNAL FROM AC-0001
DS011-TRJR-480121
DS011-TRJR-480117
3871
4291 SIGNAL
SIGNAL TO FC-0074A
FROM TC-0097 AA
DS011-TRJR-480121
DS011-TRJR-480034
3872
6341
5Cr + 3 mm 11.20 281.00 20.50 84.70
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
30-SEP-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
AVS / MAC
JAL
COMBUSTION AIR
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
RDP / MAC
JAL
FROM 011-E-0040
GAS 2"-PTG-011045301-101CS1P-S NOTE 7
WOBBE INDEX/DENSIMETER SIGNAL ON FUEL GAS NOTE 17
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
IRG / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
NOTE 7
PILOT
31
DENSITY SIGNAL ON FUEL GAS NOTE 18
21
8"-FGS-011045302-101CS2P-S
2175
DS011-TRJR-480121 3537
2178
011-F-0001 barg °C barg Gcal/h
MJR / STG
NOTE 1
19- MANUAL VALVE SHOULD BE PLACED NEXT TO THE BURNER / PILOT AND THE SECOND MANUAL VALVE SHOULD BE LOCATED ON THE FIRST HEATER PLATAFORM NEXT TO THE OBSERVATION DOOR. 20- ONE PRESSURE GAUGE EACH BURNER/PILOT. 21- IF THERE IS BREAK OF THE DIAPHRAGM, THE VALVE WILL CLOSE. 23- UPON ACTIVATION OF UC-0330 (MIN. FIRING) FUEL GAS CONTROL VALVES WILL BE FORCED TO MIN. OPENING CORRESPONDING TO MIN. HEAT RELEASE, LETTING THE COMBUSTION CONTROL LOOP IN MANUAL. 24- ZC-0330 WILL BE TRIGGERED BY PAHH-0131 AFTER 30 SEC. 25- ADJUSTABLE MIN TRAVEL STOP AT MIN PROCESS CONDITIION. 26- MINIMUM NUMBER OF FAILED PILOTS REQUIRED TO HEATER SHUTDOWNIS 3 PILOTS. 27- THIS SIGNAL IS USED IN START-UP SEQUENCE, START-UP SEQUENCE DEFINES IN SA-JER-DS011-TRJR-355006. 28- TWO PRESSURE TAPPING CONNECTIONS 3/4" SIZE ARE REQUIRED, ONE 4 DIAMETERS UPSTREAM AND THE OTHER 10 DIAMETERS DOWNSTREAM PCV. 29- ½" VALVE INSTALLED ON FILTER FLANGE.
HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
AB: AS BUILT
GAS AIR DUCT
FUEL
NOTE 6
NOTE 13 NOTE 13
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). THIS DRAWING IS VALID FOR TWIN CDU/VDU: UNITS 011 AND 012. 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 2, 9,10, 14 , 22 DELETED. 1- FUEL USED FOR START-UP GAS. 3- FOR TIGHTNESS TEST ONLY. 4- PURGE CONNECTION AT HIGH POINT. 5- DRAIN CONNECTION AT LOWEST POINT. 6- PURGE CONNECTION. 7- STEAM TRACED. 8- ADDITIONAL SHUTDOWN CONDITIONS: A- INSTRUMENT AIR SUPPLY TO THE PLANT LOW-LOW PRESSURE. B-MANUAL SHUTDOWN IN FIELD (CLOSE AND REMOTE). C-MANUAL SHUTDOWN IN CONTROL ROOM. D-PROCESS CONDITION (FLUID LOW-LOW FLOW). E- EMERGENCY SHUTDOWN BUTTON. F- PLANT SHUT DOWN. 11- LOCAL EMERGENCY SWITCH BEHIND FIREWALL OR AT SAFE LOCATION. 12- TO ATMOSPHERE AT SAFE LOCATION. 13- HEATER 011-F-0001: OP.TEMP: 281 ºC TO 366 ºC AND OP.PRESS: 11.2 barg. 15- TOTAL NUMBER OF BURNERS IS 20. (10 EACH CELL). 16- LOCAL PANEL BY VENDOR. 17- SIGNALS TAG'S : 571-AI-1003 DENSITY, 571-AI-1001 WOBBE INDEX FROM U-571. 18- SIGNAL TAG: 571-AI-1003 FROM U-571.
06
13-MAR-2013
AB
05
06-OCT-2010
04
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE HEATER BURNER CONTROL WEST
011-074 011-076 Item Tags :
011-075 011-080
011-F-0001
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480115 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480115 2271-011-PID-0021-045
REV: 06
Sheet: 1 of 1
SCALE: NONE Format:
A1
41
41
0008A THRU 0008J
40
ZC 39
NOTE 24
0330
IGNITION PERMISIVE
BXS 0008
38
ZC
UC
0330
0330
FFI
MIN. FIRING CONDITIONS
35 34
ZC 0330
33
ZC 0331
0192 31
NOTE 24
0002A THRU 0002J
THRU 0002J
35
NOTES 8,13
L
PT
PT
PI
C1
1/2" FTE
0192
0191
0188
3/4"x1/2"
3/4"
3/4"
3/4"
V
3/4"
3/4"
3/4"
0002AL THRU 0002JL
BLL 0002
BLH 0002
OFF
ON
3/4"
+
0184
CLOSED
ZHA
ZLO
ZLC
0052
0052
0052
ZYV 0052 +
S
CLOSED
ZLS 0051 C
22 DE
ZHS 0052
20
ZLS 0052 O
ZLS 0051 O
ZLS 0052 C
+
19
TO ATM NOTE 11 FO TSO
17
ZHA 0055
13
ZLO 0055
IA
10
LL
0330
0053
0053 C
ZYV 0055
ZHS 0055
ZLS 0055 O
3/4"
PT 0390
DE
ZLS 0055 C
ZV 0055 +
ATM
MIN.
2"-FGS-011046002-101CS2P-N
0053
0053 O ZHS
0053
0053
FC 0076
3/4"
3/4"
PY 0196
OP
7
PCV 0195 +
6
0196
INST.
INST.
FC 2"x1"
D FY
ZC
ZC
ZC
ZC
FMC
0332
0331
0320
0330
MASS FLOW
0076
INST.
FI
FT
0076
0076
1/2 "
INST.
PDT 0197
H
NOTE 14
3876
6382
6370
PIPING
NOTES 16- MANUAL VALVE SHOULD BE PLACED NEXT TO THE BURNER / PILOT AND THE SECOND MANUAL VALVE SHOULD BE LOCATED ON THE FIRST HEATER PLATAFORM NEXT TO THE OBSERVATION DOOR. 17- ONE PRESSURE GAUGE FOR EACH BURNER / PILOT. 18- IF THERE IS BREAK OF THE DIAPHRAM THE VALVE WILL CLOSE. 20- UP ON ACTIVATION OF UC-0330 (MIN FIRING) FUEL GAS CONTROL VALVES WILL BE FORCED TO MIN OPENING CORRESPONDING TO MIN HEAT RELEASE, LETTING THE COMBUSTION CONTROL LOOP IN MANUAL. 21- ZC-0330 WILL BE TRIGGERED BY PAHH-0193 AFTER 30 FEC. 22- ADJUSTABLE MIN TRAVEL STOP AT MIN PROCESS CONDITION. 23- MINIMUM NUMBER OF FAILED PILOTS REQUIRED TO HEATER SHUTDOWN IS 3 PILOTS. 24- THIS SIGNAL IS USED IN START-UP SEQUENCE START-UP SEQUENCE DEFINED IN SA-JER-DS011-TRJR-355006. 25- TWO PRESSURE TAPPING CONNECTIONS 3/4" SIZE ARE PROVIDED, ONE 4 DIAMETERS UPSTREAM AND THE OTHER 10 DIAMETERS DOWNSTREAM PCV. 26- 1/2" VALVE INSTALLED ON FILTER FLANGE.
HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
011-F-0001 barg °C barg Gcal/h
5 cr - 3 mm NOTE 13 11.20 281.00 NOTE 13 20.50 84.70
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
ZHA
0054
0054
20
IA
19
POSITIONER
BY-PASS
ZC
ZC
ZC
ZC
0330
0331
0332
0320
18 17
ZYV 0056
16 15
ATM ZLS 0056 C
CLOSED ZLC 0056 OPEN
ZLS 0056 O
ZLO 0056
3/4"
D
3"x2"
6"
FLC CL300
2"
8"x6" 3/4"
PV 0196 +
D FLC CL300 NOTE 22 3"x2" 3/4"
13 12 11 10
POSITIONER ZY 0056
9
ZYC 0056
8
BY-PASS D
ZHS 0056
3"
PIPING
ZHA 0056
7 6
1/2" CL300
5 4 3
PIPING
COMBUSTION AIR
2
DS011-TRJR-480121 3544
0198 INST.
1
3/4"
3/4" PIPING 3/4"
3/4"
3/4"
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
NOTE 1
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MSS / STG
AVS / MAC
JAL
8"-FGS-011046302-101CS2P-S
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MRM / FBL
RDP / MAC
JAL
NOTE 7
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
IRG / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
NOTE 6 PILOT
DS011-TRJR-480038
ZHS
21
PDT
NOTE 6
DS011-TRJR-480121
0054
ZC 0330
FROM 011-E-0040
INST.
DS011-TRJR-480121
0054
8"x6"
3/4"
NOTE 26
3/4"
FROM TC-0097 BA
ZYC
ZC 0331
1/2"
0198
FROM FY-0070A
ZY
D
PDI
WOBBE INDEX /DENSIMETER SIGNAL ON FUEL GAS
0054
ZC 0332
OPEN
PIPING
+
1
SIGNAL
0054 O
ZC 0320
+
FV 0076
3/4"
PIPING
NOTE 26 1/2 "
SIGNAL
ZLO
ATM
ZV 0056
1"CL300
3/4"
4
SIGNAL TO FC-0070A
ZLS
3/4"
D NOTE 18
+
D
H
0054
22
DE
3/4"
PT
FC
NOTE 18 D NOTE 25 1" CL300 PCV 0394 2"x1" 3/4"
NOTE 25
PDI 0197
0054 C
CLOSED
IA
SP.MIN.
8
23
14
L
PC 0196 B
24
D
+
2"x1"
2"x1"
25
NOTE 5
ZYV 0054
S
PV
9
2
ZLC
3"
ZHA
3
ZLS
FO TSO
H
0196 A
ZLS
5
3/4"
FC TSO
PC
ZLO
26
2"
2"
+
NOTE 3
IA
BY-PASS
11
V
FC TSO
0390
ZLC 0055
OPEN
12
27
NOTE 5
SP. START UP
ZLS
28
ZV 0054
PI
FC TSO
ZLC
29
8"-FGS-011046302-101CS2P-S
HH
ZC
2"x3/4"
CLOSED ATM
0330
ZHA 0051
TO ATM NOTE 11
+
S
ZC 0331
14
ZYV 0053
DE
ZC 0333
0330
S
+
15
3/4"
3/4"
0185A THRU NOTE 17 0185J
2"
D
+
+
ZV 0053
16
3/4"
0332
ZC
MIN.
3/4"-PTG-011046001-101CS1P-N
ZC
BY-PASS OPEN CLOSED
ZLO 0051
ZHS 0051
3/4"
NOTE 24
0331
MIN.
18
ZC
BY-PASS
ZV 0052
ATM
PI
S
IA
INST. PIPING
0320
ZLC 0051 OPEN
21
3/4"
ZC
0393 IA
PI 0189 NOTE 4
ZC
ZC
30
INST.
AIR DUCT
OPEN
PT
INST. PIPING
23
BY-PASS
S
24
0331
3/4"
PT 0193 LL
MIN. FIRING COND.
ZC
ATM
ZC 0331
0333
DE
FC TSO
PI 0193
MIN.
LL
PIPING
0185
UC 0330
ZC
+
ZC 0333
25
ZYV 0053
0184A THRU NOTE 17 0184J
PI
3/4"
INST. PIPING
HH
PI 0393
26
ZV 0051
ZC 0330
31
INST.
HH
NOTE 21
28
33 32
NOTE 16 PIPING
0002AL THRU 0002JL
4300
FROM AC-0002
3/4"
3/4"
2"-PTG-011046301-101CS1P-S
NOTE 3
34
2" MTE
NOTE 16
29
27
36
011-F-0001
SIGNAL
INST. PIPING
ZC
PILOT FLAME DETECTOR (FOR EACH PILOT)
LL
NOTE 4
30
38 37
BE 0002
C2
H
PI
0002A THRU NOTE 24 0002J
39
IGNITION (FOR EACH PILOT)
HH
PI 0191
32
AIR/FUEL RATIO SYSTEM
L LL AIR / FUEL RATIO 0191
BA 0002
0008AL THRU 0008JL
DE
36
ZC 0331
40
BY 0008
0008AL THRU 0008JL NOTE 23 3oo10 BS 0002 0002A
NOTE 20
37
BHS 0008
GAS
2"-PTG-011046301-101CS1P-S NOTE 7
FUEL
GAS
DENSITY GINAL ON FUEL GAS NOTE 15
31
21
2176
2174
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 2, 9, 10,12, 19 DELETED. 1- FUEL USED FOR START-UP GAS. 3- FOR TIGHTNESS TEST ONLY. 4- PURGE CONNECTION AT HIGH POINT. 5- DRAIN CONNECTION AT LOWEST POINT. 6- PURGE CONNECTION. 7- STEAM TRACED. 8- ADDITIONALSHUTDOWN CONDITIONS: A. INSTRUMENT AIR SUPPLY TO THE PLANT LOW-LOW PRESSURE. B. MANUAL SHUTDOWN IN FIELD (CLOSE AND REMOTE). C. MANUAL SHUTDOWN IN CONTROL ROOM. D. PROCESS CONDITION (FLUID LOW-LOW FLOW). E. EMERGENCY SHUTDOWN BUTTON. F. PLANT SHUTDOWN. 11- TO ATMOSPHERE AT SAFE LOCATION. 13- TOTAL NUMBER OF BURNER IS 20. (10 EACH CELL). 14- SIGNAL TAGS: 571-AI-1003 DENSITY, 571-AI-1001 WOBBEX INDEX FROM U-571 15- SIGNAL TAG: 571-AI-1003 FROM U-571 DENSITY.
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE HEATER BURNER CONTROL EAST
011-074 011-076 Item Tags :
011-075 011-080
011-F-0001
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480116 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480116 2271-011-PID-0021-046
REV: 05
Sheet: 1 of 1
SCALE: NONE Format:
A1
011-F-0001 CRUDE HEATER
41
TRIM: LPS-011047601-103CS1P / LPS-011047602-101CS1P
40 39
1-1/2"
38
INST. PIPING 37 36
PI
PT
0149
0149
011-F-0001
1-1/2"
36
PV 0395 A
NOTE 6
0-100%
34 4300 SIGNAL
0-100%
TO FUEL / AIR RATIO SYSTEM
PZT
0395 A
0395 A TRJR
PV 0395 B +
FLO
PZI
37
1-1/2" NPT +
35
35
NOTE 7
PZT 0395 B
FLO
NOTE 6
PZI 0395 B
34
NOTE 20
NOTES 1, 6, 20
33
VENDOR TRJR
VENDOR
32
PIPING 1-1/2" NPT
32
INST.
1-1/2"
31
PT 0145
PI 0145
1-1/2" NPT
1-1/2"
30
LP STEAM NOTE 14
29
40 39
INST. PIPING
38
33
41
H
TE
TI
0218
0218
31 30
LP STEAM
SEE DRAWING
29
SA-JER-DS011-TRJR-480042
HEADER BOX CONVECTION SECTION 1-1/2" NPT
0017
ZC
0107
0333
0331
ZPI 0107 A
15
1"-IAI-011047301-301CG2P-N 1"-IAI-011220308-301CG2P-N
13
PIPING
NOTE 19
INST.
S
0222
ZYV 0107
NPT INST. PIPING
TI 0222
+
1-1/2"
17 6264
PIPING MFR.
12
DE
MFR.
2"
2"
2"
D 3/4" ZLO
ZYC
ZHA
0107
0107
0107
0107
8
PI ZLS 0107 C
0147
6
INST. PIPING
5 11
ZLS 0107 O
ZY 0107
ZHS 0107
ZV 0107 +
3/4" LPT MIN
12"-LPS-011047301-101CS1P-H
NOTE 11 FC TSO
2213
3 2 1
2"
2"
PT 0397 B
PT 0397 C
0221 INST. PIPING
1-1/2" 2"
2" 1-1/2"
2"
2"
2"
2"
TI
17 16 15
0221 1-1/2"
NPT NPT NPT 1-1/2" 1-1/2" 1-1/2"
NPT
TE
18
2"
NO POCKET
NOTE 8 2"
2"
2"
1-1/2"
1/2"
1/2" 1/2" 1/2"
HS
ZC
0021
0331
14
VDU BY-PASS MODE
13
DG
12
0148
INST. 1/2" PIPING
INST. PIPING
11
1/2"
1/2" 10
2"
3/4"
HOLD 1
2"-FLU-011047301-103CS1P-P
9
INST.
PIPING
1/2"
8
1/2"
PIPING INST.
7 6
12"-LPS-011047302-101CS1P-N NOTE 2
5 4 3
SEE BURNER P&ID
SEE BURNER P&ID
SA-JER-DS011-TRJR-480115
SA-JER-DS011-TRJR-480116
ST
10"
2"
NPT 1-1/2" PT 0397 A
21 20
NO POCKET
7
2"-LPS-011047303-101CS1P-N
ZLC
9
2"-LPS-011047303-101CS1P-N
OPEN
2"-LPS-011047303-101CS1P-N
BY-PASS
CLOSED
2"-LPS-011047303-101CS1P-N
10
2"
NPT 1-1/2"
EAST CELL
0397
NOTE 18
PT 0150 C
TO RADIANT
2"
PT 0150 B
NPT 1-1/2"
NOTE 8
PIPING. ATM
11
4
PT 0150 A
2"-LPS-011047303-101CS1P-N
14
1-1/2"
TE
22
19
2"-LPS-011047304-101CS1P-N
ZC
ZC 0331
PI
ZC 0330
2"-LPS-011047304-101CS1P-N
ZHSR
ZC 0330
23
PAL 0099
HH
2"-LPS-011047304-101CS1P-N
3/4" 16
PI 0150
WEST CELL
2oo3
HH
1-1/2"
V
1-1/2" NPT
2oo3
0396
L
0453
AC 0002 A
NOTE 12
02
24
H
INSERTION CCTV CAMERA NOTE 9
0397
2"-LPS-011047304-101CS1P-N
NOTE 4 RESET
0396
PY
PIPING INST.
17
0107
AXA 0002 A
PSL 0099
1-1/2"
PT
2"-LPS-011047303-101CS1P-N
0107 L
PI
2"-LPS-011047303-101CS1P-N
ZHXS
2"-LPS-011047303-101CS1P-N
18
ES
0150
NOTE 7
4"CL150
1-1/2" NPT PIPING INST. 1-1/2"
AXS 0002 A AT 0002
0397 D
1-1/2" NPT 1-1/2"
PY
2"-LPS-011047303-101CS1P-N
ZHXS
+
1-1/2"-LPS-011047305-101CS1P-N
ZPZV 0107
ES
INSERTION CCTV CAMERA NOTE 9 H
4"CL150
0453
TO RADIANT
+
O2 NOTE 7
1-1/2"
1/2"D3/4" 12.00
19
TI
H
PI
1-1/2"
0001
0150 D
INST. PIPING
0001 A
PI
NOTE 12
AT
INST. PIPING
1-1/2"
AC
H
PT 0395
2"-LPS-011047304-101CS1P-N
0017
1-1/2"
0001 A
2"-LPS-011047304-101CS1P-N
0001 A
TE 0220
2"-LPS-011047304-101CS1P-N
PSL
1-1/2"
AXS
1-1/2" NPT
2"-LPS-011047304-101CS1P-N
AXA
1-1/2"
22
20
TE
25
1-1/2"-LPS-011047306-101CS1P-N
0220
23
21
TI 0219
TI
PC 0395
2"-LPS-011047304-101CS1P-N
24
TE 0219
NO POCKET
PAL
25
26
NO POCKET
1-1/2" NPT
26
27
NO POCKET
1-1/2" NPT
1-1/2" NPT 1-1/2" NPT 1-1/2" NPT
NO POCKET
27
28
1-1/2" NPT
NO POCKET
1-1/2" NPT 1-1/2" NPT
NO POCKET
28
2
14 3/4"
D
3/4"
D
3/4"
1
D
3/4" 10" NC
SIGNAL TO FUEL/AIR RATIO SYSTEM DS011-TRJR-480115 4291
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JVM / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JGT / FCB
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
HOLDS 1- OPERATIONAL AND DESIGN CONDITIONS.
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 3, 5,10,13,15,16 DELETED. 1- DAMPERS WILL BE PROVIDE WITH LEVERS IN ORDER TO OPERATE THEM MANUALLY. 2- DRIP HOLE AT LOW POINT. 4- PUSH BUTTON AND ZV LOCATED AT SAFE DISTANCE FROM HEATER BEHIND A FIREWALL. 6- SUPPLY BE HEATER VENDOR. 7- SAMPLING POINT. THIS SAMPLE IS FOR MONITORING THE FLUE GAS AND TAKEN BY PORTABLE ANALYZER IN SITU ACCORDING TO JERES A-102, APPENDIX A. 8- TO BE LOCATED ON FURNANCE LONG WALL (WHERE APPLICABLE). 9- REFER TO DRAWING SA-JER-DAAA-TRJR-065601 CCTV SYSTEM. 11- FOR GENERAL ENGINEERING REQUIREMENTS REFERS TO SAES-J-603. 12- WITH FLAME ARRESTOR IN O2 ANALYZER. THE O2 ANALYZERS TO BE DEENERGIZED IN CASE OF HEATER S/D. 14- STEAM COIL IS DESIGNED FOR NO FLOW. 17- STEAM TRAP TYPICAL ASSEMBLY BY PIPING. 18- ZC-0330 WILL ACTIVATE ZC-0331 IF THE PRESSURE DOES NOT DROP UNDER HH WITHIN 15 SEC. 19- AIR VESSEL TO ALLOW 3 FULL STROKES CAPACITY AND SHALL BE LOCATED OUTSIDE OF FIRE HAZARDOUS AREA. 20- ADJUSTABLE MIN TRAVEL STOP AT MIN PROCESS CONDITIONS.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE HEATER STACK AND DETAILS
011-074 011-076 Item Tags :
011-075 011-080
011-F-0001
Syst./ S-Syst.:
Electronic Filename SA-JER-DS011-TRJR-480117.pid
Discipline: PRO
99
COMPANY Document N° Contractor/Vendor Document N°
SA-JER-DS011-TRJR-480117 2271-011-PID-0021-047
REV:
05
Sheet: 1 of 1
SCALE: NONE Format:
A1
41
41
0011 A NOTE 27 THRU IGNITION BXS 0011 H PERMISSIVE 0011 BY VENDOR
39 38
0011 AL THRU 0011 HL
37
ZC
BA
0335 35
AIR/FUEL RATIO SYSTEM
PILOT FLAME DETECTOR (FOR EACH PILOT)
36
0003 0003 A THRU 0003 H
0003
0003 A THRU 0003 H
1/2" NPT.F
C2
0334
0334
L LL AIR./FUEL RATIO
PI 0219
3/4"
2"-PTG-011048301-101CS1P-S
BLL
BLH 0003
0003 OFF
ON
3/4"
UC 0334
0210
NOTE 27
ZC
0210
L
ZC
ZC 0336
FC TSO
24 HH
NOTE 3
PI 0400
PT 0400
ZC
ATM
3/4"
ZYV 0060
21
S
+
20
IA
0410 LL
ZC
ZC
ZC
ZC
0063
0063
0063
0337
0335
0321
0334
OPEN
IA CLOSED
BY-PASS
ZLC
ZLO
ZHA
0060
0060
0060
ZHS 0063
ZLS
ZLC
0059 C
0059
DE
ZLS 0063 O
17
ZHS 0060
ATM ZV 0063
+
TO ATM NOTE 11
ZHS 0059
ZHA 0059
ZYV 0061
13
ZV 0061
0337
0335
0321
0334
DE
ZLS 0061 C
NOTE 21
ZLS
3/4" FC CL300 NOTE 28 3/4"
0061
0061 O
PCV 0398
1"
+
2"x1" 3/4"
BY-PASS ZHA
ZHS
0061
0061
2
ZY 0064
ZLS 0064 O
ZC 0372
ZC 0337
ZLS 0064 C
MIN.
DE
3/4"
ZC 0334
ZC 0321
ZC 0335
PCV 0214
1"
+
2"x1" 3/4" D
NOTE 31
ES
HIXS 0047 L
ZYC
0062
0062
ZHS
ZHA
0062
0062
PY
0080
0213 ZC 0330
ZC 0372
ZC 0337
ZC 0335
ZC 0321
L
PI 0212
0335
0334
0334
START LEAK TEST CELL A
RESET OFFGAS LINE
PB
FV 0080
2" PV 0213 +
6"x4"
3/4"
FLC NOTE 25 CL300
RESET
HXS 0140 AL
HS 0070 AL
DS011-TRJR-480121
DS011-TRJR-480120
DS011-TRJR-480094
3875
3884
7745
SIGNAL
SIGNAL TO FC-0075 A
FROM 011-TC-0140 AA
SIGNAL FROM FI-0045
DS011-TRJR-480121
DS011-TRJR-480071
DS011-TRJR-480089
3877
6229
011-FA-0002-A / B
3/4"
0.31 65.00 4.00 + FV 155.00
HXS 0140 BL
20
PDT 0223
19
1"
1"
18
4"
HSR
HSR 0072 BL
1/2"
READY OFFGAS LINE
CL300
0073 BL
17 16
1"
15
BURNERS SHUT DOWN
14 13
HIXS 0046 BL
ZC 0335
ZC 0334
XL 0081 AL
XL
XA
XL
XL
XL
XL
XL
XA
XL
0071 L
0072 AL
0073 AL
0074 L
0075 L
0076 L
0077 L
0078 L
0079 L
0080 L
COMMON TRIP
LEAK TEST OK CELL A
LEAK TEST FAULT
FORCED FAN RUNNING
INDUCED FAN RUNNING
READY TO PURGE PURGE START IN COMPLETED PURGE PROGRESS
11
READY BURNERS GAS LINE CELL A
UA
10 9
0081 BL 7
READY BURNERS GAS LINE CELL B
READY PILOT GAS LINE
PURGE TRIPPED
8
XL
6 5 4
3/4" 3/4"
XL
XA
0072 BL
0073 BL
UC
XL
XL
XL
XL
XL
XL
0070 AL
0070 BL
0070 CL
0070 DL
0140 AL
0140 BL
LEAK TEST IN PROGRESS CELL B
READY TO RESET MIN FIRING CELL A
READY FOR LEAK TEST CELL A
0331
0331 3/4"
PDT 0216
21
READY FOR LEAK TEST LEAK TEST IN CELL B PROGRESS CELL A
READY TO RESET MIN FIRING CELL B
3
NOTE 7 VENT GAS
2
FROM 011-C-0007 DS011-TRJR-480094 3452
1
3/4"
3/4" 3/4"
PILOT
INST. PIPING
GAS
2"-PTG-011048301-101CS1P-S NOTE 7
WOBBE INDEX/DENSIMETER SIGNAL ON FUEL GAS
3/4" NOTE 6 FUEL
GAS 6"-FGS-011048302-101CS2P-S NOTE 7
DENSITY SIGNAL ON FUEL GAS
COMBUSTION AIR
06
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
05
06-OCT-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JVM / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
IRG / STG
RDP / MAC
JAL
FROM 011-E-0040
NOTE 15
31
NOTE 16
2182
011-F-0002 barg °C barg Gcal/h
H
PDI 0223
XL 0141 L
D
D
NOTE 6
7744
HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
NOTE 29
NOTE 29
0070 L
3"x2"
LEAK TEST LEAK TEST OK CELL B FAULT CELL B
16- SIGNAL TAG: 571-AI-1001 FROM U-571 DENSITY. 17- OP. PRESS.: 5.5 barg - 0.4 barg. OP. TEMP.: 354 TO 410 ºC. DES. PRESS.: 12 barg + FV. 18- ONE PRESSURE GAUGE EACH BURNER/PILOT/OFF GAS. 19- LOW LIMIT SWITCHES ON BURNER MANUAL VALVES TO BE USED AS PERMISSIVE FOR OFF - GAS SUPPLY OPENING. (HOLD) 20- LOW LIMIT SWITCHES ON OFF-GAS MANUAL VALVES TO BE USED AS DISCREPANCY ALARM IF ASSOCIATED BURNER MANUAL VALVE IS DETECTED CLOSE WHEN CORRESPONDING OFF-GAS MANUAL VALVE IS DETECTED NOT CLOSED. (HOLD) 21- IF THERE IS BREAK OF THE DIAPHRAGM, THE VALVE WILL CLOSE. 23- UPON ACTIVATION OF UC-0334 (MIN FIRING) FUEL GAS CONTROL VALVES WILL BE FORCED TO MIN OPENING CORRESPONDING TO MIN HEAT RELEASE, LETTING THE COMBUSTION CONTROL LOOP IN MANUAL. 24- ZC-0334 WILL BE TRIGGERED BY PAHH-0410 AFTER 30 SEC. 25- ADJUSTABLE MIN TRAVEL STOP AT MIN PROCESS CONDITION. 26- MINIMUM NUMBER OF FAILED PILOTS REQUIRED TO HEATER SHUT DOWN IS 3 PILOTS. 27- THIS SIGNAL IS USED IN START-UP SEQUENCE. START-UP SEQUENCE DEFINED IN SA-JER-DS011-TRJR-355007. 28- TWO PRESSURE TAPPING CONNECTIONS 3/4" SIZE ARE PROVIDED ONE 4 DIAMETERS UPSTREAM AND THE OTHER 10 DIAMETERS DOWN STREAM PCV. 29- INSTALLATION FROM IGNITION POINT TO BE LARGER THAN 10 METERS (L / D >100) TO AVOID ENDURANCE BURNING INSIDE THE FLAME ARRESTER. 30- TWO LEVEL LL ALARMS AT FIRST LEVEL (0.2 barg) ONLY ACTIVATE ZC-0336 AT SECOND LEVEL (0.05 barg) ACTIVATE HEATER PARTIAL S/D. 31- ½" VALVE INSTALLED ON FILTER FLANGE. FLAME ARRESTOR CAPACITY Kg/h OP. PRESS. barg OP. TEMP. °C DES. PRESS. barg DES. TEMP. °C
011-FA-0002-B
RESET
NOTE 27
AIR DUCT
SIGNAL FROM FI-0068
INST. PIPING
22
011-FA-0002-A
PB
ZC
UC
SIGNAL FROM AC-0006
24
12
1
SIGNAL FROM FY-0075 A
25
RESET PILOT RESET BURNERS GAS LINE GAS LINE CELL B CELL B
UA
PDT 0215
3/4"
PARTIAL S/D (BURNERS)
23
HISR 0046
COMMON ALARM
3"
H
26
NOTE 5
START-UP HEATER CONTROL PANEL 011-LP-F-0002 RESET RESET PILOT BURNERS START LAMP HEATER GAS LINE GAS LINE PURGE TEST SHUT DOWN CELL A CELL A HSR HS HSR HS HIXS 0073 AL 0071 L 0072 AL 0074 L 0047 BL
ZC
D
3"x2"
FLC CL300
FT
PDI 0216
D
3/4"
D
4"
FI 0080
ES
0046 A
ZC
NOTE 27
1/2" FY 0080
28
0141 L
6"x4"
SP.MIN.
TOTAL HEATER S/D
HS 0070 BL
3"-FGS-011048003-101CS2P-S
MASS FLOW
29
4"-GAS-011048001-101CH4S-S
HIXS
RESET MIN. RESET MIN. START LEAK FIRING COND FIRING COND TEST CELL B CELL A CELL B
HXS
0213 B
ZC 0334
0206 A NOTE 18 THRU 0206 H
NOTE 14 START-UP LOCAL PANEL 011-LP-F-0002
3"
H
PC FMC
NOTE 4 INST. PIPING 1" 1"
ZC
HISR 0047
LL
+
FC
PI
ZC
HH
3/4"
PV OP
30
4"
ZLO 0062
NOTE 3
3/4"
3/4" FC NOTE 28 CL300 3/4"
0010 A÷H
31
1"
ZLC 0062
ZY
PT 0212
SP.START UP
0213 A
0010 AC÷HC
PT 0207
NOTE 10
BY-PASS
TSO PT 0213
PC
2"-PTG-011048302-101CS1P-S
NOTE 31 PDI 0215
ZC 0330
0080 3/4"
H
ZV 0064
ES
POSITIONER
MIN.
FC
ZLC 0064
D 2"x1"
PIPING INST.
4 3
NOTE 21
D
5
ZLO 0064
3/4"
D 2"x1"
OPEN ZLO
FO TSO IA
ZYV 0064
XLC
PIPING INST.
0047 A
INST. PIPING
3/4"
ZLC 0061
ZYC 0064
ZHS 0064
IA CLOSED
6
0372
ZHA 0064
ATM
11
7
ZC
BY-PASS POSITIONER OPEN
FC TSO
S
ZC 0335
8
ZC
+
+
9
ZC
MIN.
3/4"-PTG-011048001-101CS1P-N
10
ZC
+
+
12
ZC
ATM
0330 FO TSO
IA
ZLS 0062 O
3/4"-FGS-011048002-101CS2P-N
ZC
15 14
2"x3/4"
S
16
TO ATM NOTE 11
BY-PASS
MIN.
ZV 0060
ZLS 0060 O
HIXS
OPEN
PIPING
ZLS 0060 C
D
DE
ZLO 0059
L
33
CLOSED
ZLS 0062 C
IA
INST.
ATM
18
ZYV 0062
S
+
ZLS 0059 O
XLS
0206
2"
0205 A THRU 0205 H
NOTE 5
ATM
ZYV 0063
OPEN
19
NOTE 20
1"
NOTE 18
2"
+
CLOSED ZLS 0063 C
0207
27
+
ZLC
OPEN
XLC 0009 A÷H
PI 0205 PIPING INST.
3/4"
FC TSO
NOTE 30
+
CLOSED
2"
NOTE 5 6"-FGS-011048302-101CS2P-S
ZV 0062
3/4"
ZLO
BY-PASS
H
1"
PT
0410
PI
3/4"
ZHA 0335
LL
D
3/4"
S
22
+
S
ZC 0335
ZC 0372
ZYV 0059
V
3/4"
HH
PI
0334
XLS 0009 AC÷HC
0211
0330
+
ZC
23
ZC
0334
ZV 0059 DE
25
34
NOTE 2
NOTE 19
2"
NOTE 4
0334
ZC
3/4"
PT
PI 0204
3/4"
PI
H
PI
NOTE 2 NOTE 18 0204A THRU 0204H
3/4"
LL
26
3/4"
32
3/4"
0003 AL THRU 0003 HL
NOTE 24 MIN. FIRING COND.
PT 0219
2"x1-1/2"
3/4"
DE
27
ZC 0335
0003 AL THRU 0003 HL
BY VENDOR
PIPING
ZC 0334
BY VENDOR
0192
3/4"
3/4"
HH
28
3/4"
PIPING
PI 0208
29
V
35
INST. PIPING
FFI
INST.
INST.
30
NOTE 2
UC NOTE 23
3/4"
1 1/2" NPT.M
C3
ZC 0334
ZC
31
2" NPT.M
C1
INST. PIPING
NOTE 4
37
NOTES 8, 13
PIPING INST.
32
011-F-0002
BE
3/4"x1/2"
MIN FIRING CONDITIONS
39
NOTE 26
34 33
40
38
BY VENDOR
BS
0003
0003 A THRU 0003 H
IGNITOR (FOR EACH PILOT)
0011 A THRU 0011 H
BHS 0011
3oo8 BY VENDOR 36
011-FA-0002-A / B OFF GAS FLAME ARRESTOR
BY VENDOR BY 0011
4"-GAS-011036004-101CH4S-S
40
5 Cr + 3 mm NOTE 17 5.50 NOTE 17 354.00 NOTE 17 12.00 41.19
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DS011-TRJR-480121 3541
21 2180
GENERAL NOTES
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- FOR GENERAL ENGINEERING REQUIREMENTS REFER TO JERES-J-603. 4- FOR NORMAL REGULATORY CONTROL INSTRUMENTATION, SEE PLANT P&ID.
REV
DATE
UTILITIES IDENTIFICATION POS.
1 2 NOTES 3 1, 9, 12, 22 DELETED. 4 2- MANUAL VALVE SHOULD BE PLACED NEXT TO BURNER / PILOT AND THE SECOND MANUAL VALVE SHOULD BE LOCATED ON THE FIRST HEATER PLATFORM NEXT TO 5 OBSERVATION DOOR. 6 3- FOR TIGHTNESS TEST ONLY. 7 4- PURGE CONNECTION AT HIGH POINT. 5- DRAIN CONNECTION AT LOWEST POINT. 8 6- FLUSH CONNECTION. 9 7- STEAM TRACED. 8- ADDITIONALSHUTDOWN CONDITIONS: 10 A. INSTRUMENT AIR SUPPLY TO THE PLANT LOW-LOW PRESSURE. 11 B. MANUAL SHUTDOWN IN FIELD (CLOSE AND REMOTE). 12 C. MANUAL SHUTDOWN IN CONTROL ROOM. 13 D. PROCESS CONDITION (FLUID LOW-LOW FLOW). E. EMERGENCY SHUTDOWN BUTTON. 14 F. PLANT SHUTDOWN. 15 10- LOCAL EMERGENCY SWITCH BEHIND FIREWALL OR IN SAFE LOCATION. 16 11- TO ATMOSPHERE AT SAFE LOCATION. 13- TOTAL NUMBER OF BURNERS (8 EACH CELL) IS 16. 17 14- START-UP LOCAL PANEL INCLUDED VENDOR SCOPE. 18 15- SIGNAL TAG´S: 571-AI-1003 DENSITY, 571-AI-1001 WOBBE/INDEX FROM U-571.
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM HEATER BURNER CONTROL WEST
011-074 011-076 Item Tags :
011-075 011-080
011-F-0002
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
011-FA-0001-A/B Electronic Filename SA-JER-DS011-TRJR-480118 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480118 2271-011-PID-0021-048
REV: 06
Sheet: 1 of 1
SCALE: NONE Format:
A1
41
41
NOTE 26 40
BXS 0014
39 38 37
BA 0004
AIR/FUEL RATIO SYSTEM
34
0334
0004A THRU 0004H
011-F-0002
ZC
ZC
0335
0334
FFI
0067
0067 O
0067 C
L
BY-PASS
OPEN
CLOSED
ZHA 0068
ZLO 0068
ZLC 0068
S
S
ATM
+
3/4" ZV 0068 +
MIN. FO TSO
15 S
0035
OPEN
CLOSED
ZHA
ZLO
ZLC
0069
0069
0069
11
ZLS 0069 O
ZC
0335
ZC
0321
S
0334
FC TSO
+
ZV 0070
IA
ZLO 0071
ZYV 0071
NOTE 3 HH
PI 0403
TO ATM NOTE 11
LL
ZHS
ZLS
ZLS
0071
0071 O
0071 C
DE
ATM
2"x3/4"
PC 0230 A
NOTE 26 ATM
H L
PT 0230
ZC 0334
3/4" 1" CL300 FC 3/4"
ZLS 0069 C
8
PCV 0404 INST.
7 6
D 2"x1"
2"x1"
3/4"
3/4"
D
D
PCV 0227 +
PIPING
+
3/4"
D
D
FC
PY
0084
0230
1" CL300 FC NOTES 20, 27 3/4" D
2"x1"
3/4"
D
ZC 0337
ZC 0372
ZC 0330
2"-PTG-011049002-101CS1P-S
5
+
ZC 0335
ZC 0321
FY 0084
PDI
H
0242
MASS FLOW
+
FI 0084
FT 0084
0242
PDI 0243
H
FROM 011-TC-0140 BA
DS011-TRJR-480121
DS011-TRJR-480075
3874
6310
FROM FI-0068
DS011-TRJR-480121
DS011-TRJR-480094
NOTE 15
3873
7765
SIGNAL
0.31 65.00 4.00 +FV 155.00
HEATERS TYPE COIL MATERIAL OP. PRESS. OP. TEMP. DES. PRESS. DUTY
ZC 0337
ZC 0372 ZC 0372
ZC 0330
011-FA-0002-A
barg °C barg Gcal/h
5.50 354.00 5 cr + 3 mm 12.00 NOTE 14 41.19 NOTE 14 NOTE 14
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
011-FA-0002-B NOTE 28
NOTE 28
PDT 0237
PDI 0237
H
19 18
ZC 0330
17
1"
OPEN
ZLC
ZLO
ZYC
ZHA
0072
0072
0072
0072
14
1"
POSITIONER BY-PASS
CLOSED
13 12
FLC CL300 PV 0230 +
3/4"
11
D FLC NOTE 24 CL300
ZLS 0072 C
ZLS 0072 O
ZY 0072
ZHS 0072
10 9
3/4"
8
D 3"-FGS-011049003-101CS2P-S
CL300 3/4" D
7 6 5 4
VENT OFF GAS
0243
PILOT GAS
3/4"
2
FROM 011-C-0007
D
DS011-TRJR-480094 3456
3/4" FUEL GAS
NOTE 6
2"-PTG-011049301-101CS1P-S NOTE 7 31
6"-FGS-011049302-101CS2P-S NOTE 7
DENSITY SIGNAL ON FUEL GAS
NOTE 16
2181
011-F-0002
22
3/4"
D
3/4"
PIPING
17- ONE PRESSURE GAUGE EACH BURNER/PILOT/OFFGAS. 18- LOW LIMIT SWITCHES ON BURNER MANUAL VALVES TO BE USED AS PERMISSIVE FOR OFF - GAS SUPPLY OPENING. (HOLD) 19- LOW LIMIT SWITCHES ON OFF-GAS MANUAL VALVES TO BE USED AS DISCREPANCY ALARM IF ASSOCIATED BURNER MANUAL VALVE IS DETECTED CLOSE WHEN CORRESPONDING OFF-GAS MANUAL VALVE IS DETECTED NOT CLOSED. (HOLD) 20- IF THERE IS BREAK OF THE DIAPHRAGM, THE VALVE WILL CLOSE. 22- UPON ACTIVATION OF UC-0334 (MIN FIRING) FUEL GAS CONTROL VALVES CONTROL WILL BE FORCED TO MIN OPENING CORRESPONDING TO MIN HEAT RELEASE, LETTING THE COMBUTION CONTROL LOOP IN MANUAL. 23- ZC-0334 WILL BE TRIGGERED BY PAHH-0406 AFTER 30 SEC. 24- ADJUSTABLE MIN TRAVEL STOP AT MIN PROCESS CONDITION 25- MINIMUM NUMBER OF FAILED PILOTS REQUIRED TO HEADER SHUTDOWN IS 3 BURNERS. 26- THIS SIGNAL IS USED IN START-UP SEQUENCE START-UP SEQUENCE DEFINED IN SA-JER-DS011-TRJR-355007. 27- TWO PRESSURE TAPPING CONNECTIONS 3/4" SIZE, ONE 4 DIAMETERS UPSTREAM AND THE OTHER 10 DIAMETERS DOWNSTREAM PCV. 28- INSTALLATION LOCATION FROM IGNITION POINT TO BE LARGER THAN 10 METERS (L/D>100) TO AVOID ENDURANCE BURNING INSIDE THE FLAME ARRESTER. 29- TWO LEVEL ALARMS. AT FIRST LEVEL (0.2 barg) ONLY ACTIVATE ZC-0336. AT SECOND LEVEL ((0.05 barg) ACTIVATE HEATER PARTIAL S/D.
011-FA-0002-A / B
ZC 0335
ZC 0337
NOTE 1 WOBBE INDEX/DENSIMETER SIGNAL ON FUEL GAS
FLAME ARRESTOR CAPACITY Kg/h OP. PRESS. barg OP. TEMP. °C DES. PRESS. barg DES. TEMP. °C
ZC 0335
PDT
INST. NOTE 6
SIGNAL FROM FY-0077-A
1"
1
3/4"
3/4"
SIGNAL
SIGNAL TO FC-0077-A
23
21
D
PIPING
7755
24
3
INST.
DS011-TRJR-480089
LL
25
4"
ATM
1/2"
3/4" FROM FI-0045
26
15
D
2
SIGNAL
D
INST. PIPING
PDT
1
D
1/2 "
1/2 "
27
IA
3/4"
FV 0084
ZC 0334
MIN 1" NOTE 7
S
INST.
SP.MIN.
28
DE
3/4"
3
ZC 0321
3"-FGS-011049003-101CS2P-S
0230 B FMC
1"
16
ZYV 0072
1/2"
3/4"
4
ZC 0334
FC TSO 3/4"
PC
OP
29
PIPING
NOTE 5
0229
NOTE 3
ZC 0321
ZV 0072
PV
D
INST.
1"
PIPING 3/4"
30
20
+
ZC
FC TSO
L
31
NOTE 26
ZV 0071 MIN.
FO TSO
SP START UP
0238
32
4"
S
+
0238
ZC
ZC 0334
ZLC 0071
H
PI
3/4"
DE
ATM CLOSED
3/4"
HH
PT 0229
ZYV 0070
2"-FGS-011049002-101CS2P-N
2"x1" NOTES 20, 27 ZHS 0069
ZC
V
6"-FGS-011049302-101CS2P-S
IA
+
+
10 9
ZC
NOTE 5
+
DE
BY-PASS
0330
3/4"
2"
2"
0406 NOTE 29
LL
ZHA 0071
ZV 0069
ZYV 0069
IA
12
0372
PT 0403
MIN.
3/4"-PTG-011049001-101CS1P-N
ZC
ZC
PI
4322
D
3/4"
3/4"
PT
0406
BY-PASS OPEN
DE
17
13
MIN. 0228 0334 FIRING COND. HH
PIPING INST. NOTE 17 0239A PI 1" THRU 0239 0239H NOTE 4
PT
3/4"
PI
UC
+
IA
ZLS 0068 C
ZC 0336
ZLS 0070 C
ZC 0334
ZV 0067
ZYV 0068
ATM
14
ZC 0334
+
DE
0335
19
TO ATM NOTE 11
ZLS 0070 O
ZC
0337
FC TSO
ZC
16
ZY 0070
1"
2"
NOTE 4
ZLC 0070
+
IA
20
ZLS 0068 O
ZLO 0070
PI
ZYV 0067
0335
ZHS 0068
ZHS 0070
3/4"
ZC
18
ZYC 0070
INST. PIPING
23
21
ZHA 0070
0226
24
22
2"
NOTE 23
PT
0240
0240A THRU 0240H
XLC 0012 -A÷H
4"-GAS-011036005-101CH4S-S
ZLS
3/4"
PI
3/4"
NOTE 18
AIR DUCT
ZLS
NOTE 17
CLOSED
BY-PASS POSITIONER OPEN
2" 3"x2"
0226
ZHS
LL
PT 0225
H
PI 25
V
3/4" 3/4"
3"x2"
26
HH
33
SIGNAL
NOTE 19
NOTE 2
INST.
XLS 0011 -AC÷HC
PIPING INST.
PI 0225
XLC 0011 A÷H
NOTE 4 3/4"
PIPING
NOTE 2
MIN.
ZLC 0067
3/4"
4" 6"x4"
ZLO 0067
NOTE 2
0241A PI THRU 0241H 0241 NOTES 17
6"x4"
ZHA 0067
27
3/4" XLS 0012 -AC÷HC
2"-PTG-011049301-101CS1P-S
CLOSED
2"x1-1/2"
3/4"
3/4"
INST. PIPING.
OPEN
35
1 1/2" NPT.M
PIPING
3/4"
PIPING INST.
BY-PASS
28
3/4"x1/2"
INST.
0335 3/4"
C3
2" NPT.M
FROM AC-0007
ZC PI 0224
NOTE 8
C1
34
OFF
0334
29
1/2" NPT.F
0004AL THRU 0004HL
BLL 0004
0004AL THRU 0004HL
ON
36
NOTE 13
ZC
30
37
BE 0004
C2
L 0193 LL AIR/FUEL RATIO
MIN. FIRING CONDITION
31
BS 0004
INST.
0334
39 38
PIPING
UC
PILOT FLAME DETECTOR (FOR EACH PILOT) NOTE 25
BLH 0004
NOTE 22
011-FA-0002-A / B OFF GAS FLAME ARRESTOR
PIPING INST.
32
ZC
BHS 0014
40
IGNITION (FOR EACH PILOT)
0014A THRU 0014H
0004A THRU 0004H
35
33
BY 0014
4"-GAS-011049001-101CH4S-S
36
IGNITION PERMISIVE 0014A THRU 0014H 0014AL THRU 0014HL 3oo8
GENERAL NOTES
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
COMBUSTION AIR DUCT
21
FRM 011-E-0040
2179
DS011-TRJR-480121 3539
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
05
06-OCT-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
IRG / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS.
1 2 1, 9, 10, 12, 21 DELETED. 2- MANUAL VALVE SHOULD BE PLACED NEXT TO BURNER / PILOT AND THE SECOND MANUAL VALVE SHOULD BE LOCATED ON THE FIRST HEATER PLATFORM NEXT TO 3 4 OBSERVATION DOOR. 3- FOR TIGHTNESS TEST ONLY. 5 4- PURGE CONNECTION AT HIGH POINT. 6 5- DRAIN CONNECTION AT LOWEST POINT. 6- FLUSH CONNECTION. 7 7- STEAM TRACED. 8 8- ADDITIONAL SHUTDOWN CONDITIONS: 9 A- INSTRUMENT AIR SUPPLY TO THE PLANT LOW-LOW PRESSURE. B-MANUAL SHUTDOWN IN FIELD (CLOSE AND REMOTE). 10 C-MANUAL SHUTDOWN IN CONTROL ROOM. 11 D-PROCESS CONDITION (FLUID LOW-LOW FLOW). 12 E- EMERGENCY SHUTDOWN BUTTON. 13 F- PLANT SHUT DOWN. 11- TO ATMOSPHERE AT SAFE LOCATION 14 13- TOTAL NUMBER OF BURNERS IS 16. 15 14- OP.PRESS.: 5.5 barg - 0.4 barg 16 OP.TEMP.: 354 TO 410ºC DES. PRESS.: 12 barg + FV. 17 15- SIGNAL TAG´S: 571-AI-1003 DENSITY, 571-AI-1001 WOBBE INDEX FROM U-571. 18 16- SIGNAL TAG´S: 571-AI-1003 DENSITY FROM U-571.
NOTES
06
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM HEATER BURNER CONTROL EAST
Project:
011-074 011-076 Item Tags :
011-075 011-080
011-F-0002
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
011-FA-0002-A/B Electronic Filename SA-JER-DS011-TRJR-480119.pid
Discipline: PRO
SA-JER-DS011-TRJR-480119 2271-011-PID-0021-049
REV:
06
Sheet: 1 of 1
SCALE: NONE Format:
A1
41
41
011-F-0002 VACUUM HEATER
40
40
TRIM: LPS-011050601-101CS1P / LPS-011050602-103CS1P
SIGNAL
39 4322 TO FUELL / AIR RATIO SYSTEM
39
TUBING 38
38
37 36
1-1/2" 1-1/2"
PI
PT
0244
0244
37
1-1/2" NPT 36
PV 0408
INST. PIPING
+
35
35
NOTE 7
34
PZI
PZT 0408
0408
011-F-0002
NOTE 6
TUBING
1-1/2" NPT
33 32
PIPING INST. 1-1/2" 1-1/2"
NPT
PT
PI
0246
0246
1-1/2" NPT
30
LP STEAM NOTE 14
26
1-1/2"
NPT
1-1/2"
NPT
1-1/2"
NPT
22
AXA
AXS
PSL
0006 A
0006 A
0128
21
1/2"D3/4" 12.00 +
20
ZPZV 0108
19
ZHXS 0108
+
AT
0006
0006
PI 0407
RESET
3/4"
17
ES
ZHSR 0108
ZPI 0108 A
ZC 0338
ZHXS 0108 L
PI 0248 D
H
4" CL150 PT 0407
WEST CELL
2oo3
INST.
S
+
17 6265
13
PIPING MFR.
12
MFR. PIPING.
DE
D
ATM
3/4" 11
PI 0248
1-1/2" NPT
NPT
ZC
0334
0336
TE 0456
NOTE 16
4" CL150
NOTE 7
0335
PT
0238
1-1/2" 1-1/2"
1-1/2"
TI 0456
PSL
PAL
0297
0297
TE 0239
PT
1-1/2"
22
AC 0007 A
21 20
H PI 0411 D
19 18
TI 0239
1-1/2"
AXA 0007 A
NOTE 12
EAST CELL
1-1/2" 0411 A 0411 B 0411 C NPT INST. PIPING 1-1/2" 1-1/2" 1-1/2"
1-1/2"
23
H
0410
PT
24
0236
H
INSERTION CCTV CAMERA NOTE 9 PI
0411
PT PT PT 0248 A 0248 B 0248 C INST. PIPING 1-1/2" 1-1/2" 1-1/2"
TI
TI
AT 0007
HH
PI
26
AXS 0007 A
PY 0411
ZC
27
25
1-1/2" NPT
ZC
28
TE 0236
ZC
1-1/2"
1-1/2"
1-1/2" 1-1/2"
17 16 15
DG
2"
2"
2"
2"
2"
2"
2"
2" 1-1/2" PIPING INST.
2"
2"
1-1/2"
2"
2"
2"
2"
PIPING INST.
1/2"
1/2" 1/2" 1/2"
INST. 1/2" PIPING
0250
4
11 10
2"
3/4"
HOLD 1 PIPING
2"-FLU-011050301-101CS1P-P 1/2" 1/2"
9
INST.
PIPING INST.
8
NO POCKET
SEE BURNER P&ID SA-JER-DS011-TRJR-480119
NO POCKET
7
NO POCKET
2"-LPS-011050310-101CS1P-N
2"-LPS-011050309-101CS1P-N
2"-LPS-011050308-101CS1P-N
ZHS 0108
2"-LPS-011050307-101CS1P-N
ZY 0108
2"-LPS-011050306-101CS1P-N
ZLS 0108 O
2"-LPS-011050305-101CS1P-N
ZLS 0108 C
NOTE 11
2"-LPS-011050304-101CS1P-N
PI
2"-LPS-011050310-101CS1P-N
5
SEE BURNER P&ID SA-JER-DS011-TRJR-480118
2"-LPS-011050309-101CS1P-N
6
2"-LPS-011050308-101CS1P-N
ZHA 0108
2"-LPS-011050307-101CS1P-N
ZYC 0108
2"-LPS-011050306-101CS1P-N
ZLO 0108
2"-LPS-011050305-101CS1P-N
ZLC 0108
2"-LPS-011050304-101CS1P-N
7
BY-PASS
OPEN
12
INST. PIPING
9
CLOSED
13
0249
10
8
14
NPT NPT NPT 1-1/2" 1-1/2" 1-1/2" NOTE 8
NPT NPT NPT NOTE 8 1-1/2" 1-1/2" 1-1/2"
TO RADIANT
PIPING
1-1/2"
2oo3
TE 0238 1-1/2"-LPS-011050311-101CS1P-N
1"-IAI-011220309-301CG2P-N 14
NPT
NPT
0334
HH
H
ZYV 0108
1-1/2" 1-1/2" 1-1/2" 1-1/2"
1-1/2" NPT
1-1/2"
1-1/2" ZC 0336
1-1/2" NPT PIPING INST. 1-1/2"
NPT
INST. PIPING
H
PY 0248
1"-IAI-011050301-301CG2P-N NOTE 17
TE 0237
PT 0408
L
NOTE 4
15
TI 0237
O2 NOTE 12 NOTE 7 INSERTION CCTV CAMERA NOTE 9
ES
V
18
16
AC
ZC 0335
ZC 0335
1-1/2"
TO RADIANT
23
29
NOTE 16
PAL 0128
30
LP STEAM
HEADER BOX CONVECTION SECTION
PC 0408
31
NO POCKET
27
24
H
SEE DRAWING SA-JER-DS011-TRJR-480079
28
25
TI 0235
1-1/2"-LPS-011050312-101CS1P-N
29
TE 0235
NO POCKET
1-1/2"
31
NO POCKET
32
34
NO POCKET
33
FLO NOTES 1, 6, 18
6 5 4
ZV 0108 +
3 11
2
INST. PIPING 12"-LPS-011050301-101CS1P-H
3
3/4" LPT
MIN NOTE 2
12"-LPS-011050302-101CS1P-N
2
FC TSO
2185
1
1
ST
10" 14 3/4" D
3/4" D
2"-LPS-011050304-101CS1P-N
NOTE 15 3/4" D
3/4" SIGNAL TO FUEL/AIR RATIO SYSTEM DS011-TRJR-480118
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS/ MAC
JAL
2"-LPS-011050306-101CS1P-N
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS/ MAC
JAL
2"-LPS-011050307-101CS1P-N
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / FBL
AVS/ MAC
JAL
2"-LPS-011050308-101CS1P-N
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / FBL
RDP / MAC
JAL
2"-LPS-011050309-101CS1P-N
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JGT / FCB
RDP / MAC
JAL
2"-LPS-011050305-101CS1P-N
NC
3884
2"-LPS-011050310-101CS1P-N
HOLDS 1- OPERATIONAL AND DESIGN CONDITIONS.
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 10, 13 DELETED. 1- DAMPERS WILL BE PROVIDED WITH LEVERS IN ORDER TO OPERATE THEM MANUALLY. 2- DRIP HOLE AT LOW POINT. 3- DRAFT GAUGE REFER TO HOOK-UP INCLUDE ON DOC Nº SA-JER-DS011-TRJR-445002. 4- PUSH BUTTON AND ZV LOCATED AT SAFE DISTANCE FROM HEATER BEHIND A FIREWALL. 5- ANALYSER TO BE LOCATED ON F-0001 AND F-0002 COMMON STACK. 6- SUPPLY BY HEATER VENDOR. 7- SAMPLING POINT. THIS SAMPLE IS FOR MONITORING THE FLUE GAS AND TAKEN BY PORTABLE ANALYZER IN SITU ACCORDING TO JERES-A-102, APPENDIX A. 8- TO BE LOCATED ON FURNANCE LONG WALL (WHERE APPLICABLE). 9- REFER TO DRAWING SA-JER-DSAAA-TRJR-A65601 CCTV SYSTEM. 11- FOR GENERAL ENGINEERING REQUIREMENT REFER TO SAES-J-603. 12- WITH FLAME ARRESTOR IN 02 ANALYZER. THE O2 ANALYZERS TO BE DEENERGIZED IN CASE OF HEATER S/D. 14- STEAM COIL IS DESIGNED FOR NO FLOW. 15- STEAM TRAP TYPICAL ASSEMBLY BY PIPING. 16- ZC-0334 WILL ACTIVATE ZC-0335 IF THE PRESSURE DOES NOT DRUP UNDER HH WITHIN 15 sec. 17- AIR VESSEL TO ALLOW 3 FULL STROKES CAPACITIES AND SHALL BE LOCATED OUTSIDE OF FIRE HAZARDOUS AREA. 18- ADJUSTABLE MIN TRAVEL STOP AT MIN PROCESS CONDITIONS. This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
REV
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
Item Tags : 011-F-0002
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM HEATER STACK AND DETAILS ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480120 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480120 2271-011-PID-0021-050
REV: 05
Sheet: 1 of 1
SCALE: NONE Format:
A1
011-F-0001 / 02
011-E-0040 AIR PREHEATER FOR CDU/VDU HEATERS
AI 0005 A
AT 0005
AXS 0005 A
39
NOTES 15, 16 OPACITY
AXS 0005 A
4" CL150
4" CL150
41
CRUDE / VACUUM HEATHER TRIM: AIR-011051601-103CS1
NOTE 8 NOTE 7
AT 0003 SO 2 AXS 0003 A
NOTE 17
DETAIL "A"
NOTE 1
NOTE 5
HV 0015
38
HLS 0015 O
HLO 0015
+
35
FLO TSO
FLUE GAS DUCT
38 37
AXA
0004 O 2 AXS
NOTE 1
FAULT
AXA 0003 A
AT
36
0004
36
FAULT
AXA
0004 A
35
DETAIL "A"
0004 A
1"-LPS-011071792-101CS1P-H
34
TT 0224
1 1/2" NPT NOTE 5 INST. PIPING
32
PI 0154
31 30
FMO
TC 0032
HC
+
H
PI 0158
1-1/2" NPT
2155
FLC
FMC
11
ZC
ZC
0332
0331
0335
11719
1" CL150
0159
XA
0003 SO 2
0015 NOTE 14
1-1/2" NPT
8"
25 24
+
1-1/2" NPT
8"
0223
3/4"
TT 0223
D
0165
22
TC
FC
PI
23
FLUE GAS DUCT
TV 0223
D
INST. PIPING
011-E-0041
1 1/2" NPT
NOTE 1
NOTE 1
NOTE 5
011-E-0040 3"-LPS-011051302-101CS1P-H
19 18 17 16 15
NOTE 5
TT 0032 B
SKIN
TE 0032 C
TI 0032 B
TT 0032 C
TI 0032 C
TI 0225
3"x1-1/2"
0160
0161
0161
H
TT 0225
L
TI 0226
L
PI 0157
BY VENDOR PV NOTE 9,18 0159 011-K-0003
7
3"-LPC-011051301-101CS1P-H
+
FY
TI
0070 A
0231
1/2" FT
FT 0074 A
1/2" 0070 B
1/2"
NOTE 5
1 1/2" NPT
FY
TI
0074 A
0227
FC 0077
I.A 3/4"
3/4" NC
INST. PIPING KM 0003
2"-OLW-011051301-101CS1P-N
M
L
ZC
ZC
0331
0330
FV 0077
L
FLO
AIR DUCT
2156
HS
UC
0332
0332
FROM 011-K-0002A/B/C DS011-TRJR-480269 8129
011-K-0003
IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
NOTE 19
011-E-0041 FIN TUBE 0.00 68.00 100.00
160.00 139.00 7.00 290.00
FMC 8
ZC 0331
7 6 5
ZC 0331
4
AIR DUCT
AIR DUCT
TO 011-F-0002
NOTE 13
STOP SIGNAL
PDI 0156
L SIGNAL
DS011-TRJR-480269
SIGNAL TO FUEL/AIR RATIO SYSTEM DS011-TRJR-480116
SIGNAL FROM FUEL/AIR RATIO SYSTEM DS011-TRJR-480116
8130
3876
6382
TO 011-PY-0160A/B/C
GENERAL NOTES
SHELL/TUBE SHELL/TUBE
9
3
011-K-0003 FLUE GAS INDUCED FAN
AIR
011-E-0040 TUBULAR 2.00 2.00 320.00 68.00 175.00 228.00 0.10 0.10 350.00 1352.0 9.22
L
DS011-TRJR-480119 3539
SIGNAL TO FUEL/AIR RATIO SYSTEM DS011-TRJR-480118
SIGNAL FROM FUEL/AIR RATIO SYSTEM DS011-TRJR-480118
3875
3877
COMBUSTION AIR DUCT
2
TO 011-F-0002 DS011-TRJR-480118 3541
1
PDT 0156
14
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
10
FLO NOTE 5
UC 0331
COMBUSTION AIR
OLW
barg °C barg °C
11
MCC ZC 0331
200600.0 0.00 175.00
FC 0075
ZC 0331
2 1
FV 0075
NOTE 10
0334
+
14
+
ZC
L FMC
1 1/2" NPT
12
NOTE 11
FV 0074
15
13
LL
FLO NOTE 5 FMC
+
UC 0331
TYPE 3
NOTE 5
FV 0070
FMC
INST. PIPING
FC
FT
0228
NOTE 5 UC 0331
16
1/2"
TI
+
NOTE 10 0074
FY 0075 A
0077
0331
FLO
TT 0228
FI
NOTE 10
1/2"
0075 C
2oo3
1 1/2" NPT
0075 B
NOTE 5
1 1/2" NPT
0077 A
1/2"
0075 A
17
FT
1/2" 1/2"
NOTE 5
FY
UC
NOTE 11
NOTE 10
FT 0074 B
1/2"
TT 0227 2oo3
FC
1/2"
FT 0074 C
LL
1-1/2" NPT
1/2"
TT 0232
1/2" FT
FT 1/2" 0077 B
1/2" 1/2"
NOTE 5 1/2 "
FI
0070 FLO
18
NOTE 11
0070 INST. PIPING
3
NOTE 11 1/2"
TI 0232
19
1/2"
FT 0077 A
FI 0074
1/2"
20 LL
2oo3 L
D 8
21
FI 0075
0077 C
TT
3/4"
4
22
FT
1/2"
PLS 0159 C
23
0334
0330
PLC 0159
1 1/2" NPT
ZC
NOTE 1
TY 0032
0231
Z 0011
3"
5
L
ZC
FT 0070 A
1 1/2" NPT
26
24
L
BY VENDOR
6
14
INST. PIPING
1-1/2" NPT
1/2"
NC
3"x1-1/2"
F 0002
2oo3
INST. PIPING
3/4"
9
TE 0032 B
TI 0032 A
1-1/2" NPT
3/4"
10
PI
FT 0070 C
13
1-1/2"
TT 0032 A
27
NOTE 20
LL
PI 0155
11
PT
AIR DUCT
SKIN
14
12
PT
1-1/2" NPT NOTE 5 TE 0032 A SKIN
28
25
INST. PIPING
1-1/2" NPT
2
ST
0160
PI 0153
21 20
PC
29
0004 O
UC 0332 F 0001
30
AT
INST PIPING
27 26
32
AT
8"-LPS-011051301-101CS1P-H
3/4"
33
PIPING INST
31
PT
0159
UC
34
11
1-1/2" NPT
PT 0158
L
PC
29 28
0015
NOTE 1
TV 0032
FMO
INST. PIPING
TI 0224
33
BLOWERS TYPE FLOW OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP.
39
OPEN
UC 0332
37
40
AI 0003
AIR DUCT
40
011-E-0041 STEAM/AIR PREHEATER FOR CDU/VDU HEATERS
AIR DUCT
41
NOTE 12
5877.0 3.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
COMBUSTION AIR DUCT TO 011-F-0001 DS011-TRJR-480116 3544
06
13-MAR-2013
AB
SIGNAL TO FUEL/AIR RATIO SYSTEM DS011-TRJR-480115
05
30-SEP-2011
04
3871
SIGNAL FROM FUEL/AIR RATIO SYSTEM DS011-TRJR-480115 3872
COMBUSTION AIR DUCT TO 011-F-0001 DS011-TRJR-480115 3537
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- SUPPLIER TO VERIFY FULL COMPLIANCE WITH JERES J-603. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER NOTES 4 POTABLE WATER 2,3,4,6 DELETED. 5 DEMI WATER 1- TIGHT SHUT-OFF PLATE. 6 N.A. 5- SUPPLY BY HEATER VENDOR. 7 7- LOCATED IN ANALIZER LOCAL PANEL 011-ALP-0001 SEE PID SA-JER-DS011-TRJR-480291. N.A. 8- REQUIRED FOUR SAMPLING POINTS IN STACK 90° APART. 8 N.A. 9- INLET DAMPERS PROVIDE BY VENDOR. 9 HP STEAM 10- OUTPUT SIGNAL FROM AIR FLOW CONTROLLERS OP>90% ACTIVATE THE UC-0331. 10 MP STEAM 11- NOT LOW AIR FLOW USED IN PURGE CYCLE. 11 LP STEAM 12- FUEL GAS SURFACE=2893 m2. AIR SURFACE=2778 m2 13- THE SHUTDOWN OF THE COMBUSTION AIR FAN BY INTERLOCK ZC-0335 SHALL BE AVOIDED DURING VDU BY-PASS OPERATION. 12 HP CONDENSATE 14- DISCREPANCY ALARM SAHLL BE TRIGGERED IF K-0003 IS STOP AND HV-0015 IS NOT OPEN. 13 MP CONDENSATE 15- REQUIRED ANOTHER CONNECTION IN STACK 180° APART. 16- LOCATED IN SELF STANDING RACK. 14 LP CONDENSATE 17- SAMPLE PROBE AND SAMPLE LINE SHALL BE INDEPENDENTLY TRACED WITH LPS. 15 BFW 18- ADJUSTABLE MIN TRAVEL STOP AT MIN PROCESS CONDITIONS. 16 PLANT AIR 19- UNITS IN Kg/h. 17 INSTRUMENT AIR 20-STEAM TRAP TYPICAL ARRAGEMENT BY PIPING. 18 N.A.
SIGNAL TO FUEL/AIR RATIO SYSTEM DS011-TRJR-480119
SIGNAL FROM FUEL/AIR RATIO SYSTEM DS011-TRJR-480119
3873
3874
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS/ MAC
JAL
14-JUL-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS/ MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS/ MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB/ STG
AVS/ MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MRM / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JGT / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 COMBUSTION AIR PREHEATING
011-074 011-076 Item Tags :
011-075 011-080
011-E-0041, 011-E-0040, 011-K-0003, 011-F-0001 / 0002
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480121.pid
Discipline: PRO
SA-JER-DS011-TRJR-480121 2271-011-PID-0021-051
REV:
06
Sheet: 1 of 1
SCALE: NONE Format:
A1
41
41
011-D-0010 TEMPERED WATER DRUM
40
40
TRIM: PRW-011052601-101CS2P / PRW-011052602-103CS2P INSULATION: P
39
39
38
38
37
37
36
36
ATM 10"-GAS-011052001-101CS2P-P
35 34
35 34
10" V
33
33
32
32
31
31
3/4"
30
NC
2"
28
LG 0109
27 26
NOTE 2
GLASS
2"
2" L1B 2"
2"
6"
L3B
2"
28 27
NOTE 2 H
LC
LT
LT
LI
0110
0110
0108
0108
25 24
2" 1/4"
23
2"
22
29
PIPING INST.
L2B
1/4"
25
INST. PIPING
2" L2A
26
L
2"
24
2"
2" L1A
23
MIN.
L3A
3/4"
D
2"
INST. PIPING
22
S
UC 2"
NC
20
A1 D
2"-PRW-011052017-101CS2P-P
19
2" 10"
18
19
NOTE 5
17
NOTE 3
2"-OLW-011052301-101CS1P-N
16
20
18
2" 101CS2P 101CS1P
17
011-D-0010
21
2"-PRW-011052018-101CS2P-N
NOTE 1
3/4"
PIPING
27203 mm
INSTR.
21
30
6"-PRW-011052006-101CS2P-N
B1
INST.
MIN.
29
PIPING
OLW
16
15
15
14
14
LV 0110 +
15
12
2"-BFW-011052301-101CS1P-H
2"x1"
NNF NOTE 4
2165
OLW
3/4"
FC 1" CL300
D
13
2"x1" 3/4"
2"-PRW-011052001-101CS2P-H
2"-BFW-011052001-101CS1P-H 101CS1P 101CS2P
13
D
11
12
MIN
11
10"-PRW-011052001-101CS2P-P
10
2"x1"
9
1"
TEMPERED WATER TO 011-G-0022A/B
10"-PRW-011052001-101CS2P-P
10 4325
2"x1"
9
NC
8 7
8 7
3/4"-PRW-011052009-101CS2P-P
6
6
5
5
2"x3/4" 4
4
3
3
2
2
101CS2P 101CS1P
1
2"-OLW-011052302-101CS1P-N
1
OLW
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JVM / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
01
11-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JVM / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JGT / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS 2271-000-PID-0021-001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1- AT LEAST ONE METER ABOVE HIGHEST POINT OF THE TEMPERED WATER LOOP. 2- ENSURE THAT NOZZLES FOR LEVEL TRANSMITTER ARE AT THE SAME ELEVATION. 3- BIDIRECTIONAL EQUALIZING LINE. DRUM TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
mm mm barg °C barg °C
011-D-0010 VERTICAL 2300.0 792.0 0.00 105.00 3.50 150.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
4- FILLING LINE. 5- FOR NOZZLES DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 011-075 011-080
Item Tags :
011-D-0010
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 TEMPERED WATER DRUM ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480122.pid
Discipline: PRO
SA-JER-DS011-TRJR-480122 2271-011-PID-0021-052
REV:
05
Sheet: 1 of 3
SCALE: NONE Format:
A1
41
41
011-A-0007-A/B / C/D / E/F TEMPERED WATER COOLER
40
40
39
39
12"-PRW-011038001-101CS2P-P
38 37
0-50%
TEMPERED WATER FROM 011-E-0030 4333
37
SPLIT RANGE
TY
50-100% 0230
36
38
36
TV 0230 A +
35 34
3/4" D 33
TV 0230 B
6"
8"x6"
32 31
8" CL300
12"x8"
30
34
3/4" D
NC
FO
8"
8"x6"
+
12"x8"
31
FC CL300
33
3/4"
32
35
8"
8"-PRW-011052010-101CS2P-P
30
29
29
2"
28
28
V 27
27
12"
12"
26
26
NOTE 7
25
25
24
24
23
6" 6"
22
011-A-0007-A/B
21
NOTES 2,3,4,5
N1
N2
N4
011-A-0007-C/D
N2
N4
D
6"
NOTES 2,3,4,5
N1
N2
6"
011-A-0007-E/F
N1
NOTES 2,3,4,5
N2
N2
D
22
6" N1 N4
N4
D
D
21
N2 6"
6"
6"
D
N4
N4
23
6"
6"
N1
6"
6"
6" 6"
6"
N1
20
6"
6"
6"
D
20
19
19
MCC
MCC TYP. 7
TYP.8
15
ZC 0415
MCC
6"
MCC
TYP. 8
6" ZC 0415
TYP. 7
17
1-1/2"
6"
6"
18
M
M 1-1/2"
16
M
M 1-1/2"
VSDS 6" NOTE 5
1-1/2"
17
M 1-1/2"
M
1-1/2"
18
6" ZC 0415
MCC
MCC TYP. 8
16
TYP. 7
15 14
13 12
MA
MA
MA
MA
MA
MA
0007 A
0007 B
0007 C
0007 D
0007 E
0007 F
NOTE 6
NOTE 6
NOTE 6
NOTE 6
NOTE 6
NOTE 6
8"-PRW-011052010-101CS2P-H
14
11 10
4325
TEMPERED WATER FROM 011-D-0010
10"-PRW-011052001-101CS2P-P
9
13 12
TC 0230
TI 0229
H
11
L
10 9
1-1/2"-PRW-011052011-101CS2P-P
8
8
6 5 4 3
NO POCKET
16"x12" NOTE 7 16"x12"
12"-PRW-011052002-101CS2P-H
12"-PRW-011052002-101CS2P-H
TT 0230
1-1/2"-PRW-011052011-101CS2P-P
12" 7
TT 0229
7 6
CL300 2"
CL300 2"
16"-PRW-011052002-101CS2P-H
10ø MIN.
TEMPERED WATER TO 011-G-0022 A/B
5 4335
4 3
2
2
1
1
2"x1-1/2"
101CS2P 2"-OLW-011052306-101CS1P-N
101CS1P
OLW
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1- OP. TEMP. ºC IN / OUT : 85 / 65. 2- 1% SLOPE IN LAST PASS OF TUBE IS TO BE CONSIDERED. 3- AIR COOLER HAS 3 BAYS WITH 2 MOTORS/FANS EACH AND 2 BUNDLES PER BAY. 4- SHUTDOWN PROTECTION DEVICES 2 ACCELEROMETERS SHALL BE PROVIDED. 5- ONE HALF OF THE MOTORS ASSOCIATED TO THE BAYS SHOULD BE CONTROLLED BY VARIABLE SPEED PRIVE. 6- VIBRATION TRIP IS REQUIRED FOR EACH MOTOR TYPICAL. 7- PIPING ARRANGEMENT TO BE SIMMETRICAL. AIRFINS TYPE SURFACE OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP DUTY
m² barg °C barg °C Gcal/h
011-A-0007-A/B FORCED 1287.0 2.00 85.00 NOTE 1 7.00 150.00 11.82
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JVM / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 TEMPERED WATER COOLER
011-074 011-076 Item Tags :
011-075 011-080
ORIGINAL SIGNED IN PROJECT FILE
011-A-0007A/B-C/D-E/F
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480123 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480123 2271-011-PID-0021-052
REV: 05
Sheet: 2 of 3
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37 4333
TEMPERED WATER TO 011-A-0007
12"-PRW-011038001-101CS2P-P
37
36
36
35
35
34
34
33
33
32
32
31
31
FV 0073 +
FC 0073 A
30
16"-PRW-011052002-101CS2P-H 27
INST. PIPING
26 25
CL300
SC
26 25
011-SC-0063 TYPE 7
24
NOTE 5
3/4"-PRW-011052019-101CS2P-P
1/2"
PIPING 1/2" INST.
27
12"x6"
NC
12"-PRW-011052003-101CS2P-H
23
28
6"
1/2"
24
29
CL300
12"x6" 1/2"
12"-PRW-011052004-101CS2P-P
FO
3/4" D
FT 0073 A
28
8" 12"x8"
12"x8"
12"-PRW-011052004-101CS2P-P
29
30
NOTE 6
23
3/4"-PRW-011052020-101CS2P-P
22
22
FT NOTE 3
MIN.
2"
21
UC
UC
LPT
LPT
MIN.
20
NOTE 3
MIN.
2"
0073 B
MIN.
20
19
NOTE 2
18
21
19
FI 0073 B L
NOTE 2
18
11 10 9 8
INST. PIPING
3/4"
3/4" 12"x8"
/4" 1"x3
2"
M
2"-PRW-011052016-101CS2P-P PI
10
0152
CL300
/4" 1"x3 CL300
3/4" WATER TO OLW
CL300
13
11
3/4" 12"x8"
NOTE 1 16"x10"
3/4"-PRW-011052003-101CS2P-P
2"
DS011-TRJR-480248 10791
NOTE 3
7
12"-PRW-011052014-101CS2P-H
LPT
CL300
14
PIPING INST.
011-G-0022-B NOTE 4
PI 0151
15
12
INST. PIPING
3/4"
NOTE 4 NOTE 1 16"x10"
0288
PIPING INST.
011-G-0022-A
LPT
PI
16
M
3/4"-PRW-011052014-101CS2P-P
9
3/4"
12"-PRW-011038001-101CS2P-P
16"-PRW-011052002-101CS2P-H
12
PI 0287
MIN.
13
16"-PRW-011052013-101CS2P-H
14
2"-PRW-011052015-101CS2P-P
15
MIN.
16
12"-PRW-011052003-101CS2P-H
17
16"-PRW-011052012-101CS2P-H
17
WATER TO OLW DS011-TRJR-480248 10792
NOTE 3
2"-PRW-011052015-101CS2P-P
2"-PRW-011052016-101CS2P-P
6 5
4335
ZC 0399
TEMPERED WATER FROM 011-A-0007 A/C
TYP. 3
4 3
ZC 0399
MCC 101CS2P 101CS1P
MCC
NC TYP. 3
2"-OLW-011052303-101CS1P-N
MG
MG
0022 A
0022 B
101CS2P 101CS1P
NC 2"-OLW-011052304-101CS1P-N
12"-PRW-011052003-101CS2P-H
OLW
1
011-G-0022-A / B TEMPERED WATER PUMPS
TO 011-E-0030 DS011-TRJR-480100 3482
4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1- PROVIDE A STRAIGHT LENGTH OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER IMMEDIATELY UPSTREAM OF THE NOZZLE. PROVIDE A CONNECTION FOR PI. 2- CHECK VALVE SHALL BE INSTALLED HORIZONTALLY. 3- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
m³/h barg bar barg °C kg/m³
011-G-0022-A / B CENTRIFUGAL 605.0 4.40 2.39 6.00 65.00 981.0
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
4- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JER-DS011-TRJR-480248. 5- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS011-TRJR-480274. 6- MAXIMUM TRAVEL STOP IS REQUIRED AT MAXIMUM CONDITION (CV=427.78).
4
05
13-MAR-2013
AB
04
30-SEP-2011
03
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / FCB
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MVF / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS.
2
DS011-TRJR-480100 3481
TEMPERED WATER
3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED.
5
FROM 011-E-0030
INSULATION:
2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
6
TEMPERED WATER
OLW
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001).
7
3
2
GENERAL NOTES
8
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080
011-G-0022 A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 TEMPERED WATER PUMPS ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480124 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480124 2271-011-PID-0021-052
REV: 05
Sheet: 3 of 3
SCALE: NONE Format:
A1
41
41
011-D-0031 DEMULSIFIER DRUM
40
011-X-0003 DEMULSIFIER INJECTION PACKAGE
40
39
39
38
NOTE 13
3"-GAS-011053301-101SC1P-N
NOTE 15
37
V CL300 2"x1" A
2" CL300
35
2"
NOTE 12 CL300 2"x1/2"
L3
34
2"
2"
PIPING
33
2"
INST.
L1A
32
CL300
MAG LG
20" ID
0123
29
NOTE 6
2" L1B
INST. PIPING
28
M
CL300
INST.
PIPING
27
B1 D CL300 2"
2"
CL300
NC
32 31
011-X-0003
30 29
1"-CHP-011053409-101SC1P-N
28
890 mm NOTE 11
31 30
34
L2
1"-CHP-011053410-101SC1P-N
33
36
CL300 2"-CHP-011053404-101SC1P-N S1
1/2"-CHP-011053402-101SC1P-N
35
37
3" NOTES 5,13
36
38
011-D-0031
27
2"x1/2"
1"-CHP-011053408-101SC1P-N 26
23 22
25
1"-CHP-011053410-101SC1P-N 24
1/2"
VENDOR TRJR
22
21
1"x1/2"
1/2"-CHP-011053406-106SC1P-N 1/2" 1/2"-CHP-011053401-101SC1P-N
1/2"-CHP-011053401-101SC1P-N
18 17 16 15 14 13
1/2"-CHP-011053406-106SC1P-N 1/2"-CHP-011053401-101SC1P-N
1/2"-CHP-011053411-101SC1P-N
NOTE 12,17
NOTE 12,17
1"D1" 19.20
1"D1" 19.20
+
12
1/2"
CL300
LO FB
1"x1/2"
1/2" NOTE 7
NOTE 7
10
1/2" 1/2"
9
0254
011-G-0030-A
8
PIPING
1/2" 1/2"
NOTE 13
5
3 2 1
D
1/2"
PIPING
1/2"
MG
1/2"
NOTE 13
MG
11
VI
INST.
PIPING
1/2" 1/2"
D
1/2" D
MG
NOTE 13 TYP. 3
NOTE 13
MG
MCC
0031 A
0031 B
DEMULSIFIER
ZC 0363 ZC
NOTE 14
011-G-0030-A / B DEMULSIFIER PUMPS
0.0 45 3.50 13.70 47.00 950.0
NOTE 8
011-G-0031-A / B 0.0 30 18.00 56.30 47.00 950.0
6 5
DEMULSIFIER
3
DEMULSIFIER
TO 011-G-0001
TO 011-D-0001
TO 011-D-0002
DS011-TRJR-480001 2693
DS011-TRJR-480010 2922
DS011-TRJR-480013 2938
2 1
BY CIVIL
OLW
011-G-0031-A / B DEMULSIFIER PUMPS GENERAL NOTES
m³/h barg bar barg °C kg/m³
7
0397
NC NOTE 16
011-G-0030-A / B
8
4
NOTES 9,13
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
9
INST.
1/2"
M
TYP. 3
10
PI 0448
011-G-0031-B
NOTE 13
MCC
0030 B
1/2"
1/2" D
M
12
1/2"
1/2"
D
NOTE 13
MCC
0030 A
D
TYP. 3
NOTE 13
PIPING
1/2"
M
TYP. 3
INST.
13
2"x1"
PI 0412
011-G-0031-A
1/2"
D
NOTE 13
MCC
2"-CHP-011053403-101SC1P-N
4
INST.
1/2"
1"x1/2"
NOTE 7 1/2"
1/2"
14
1/2"
VI
PI 0253
011-G-0030-B 1/2"
1/2"
M
6
1/2"
1/2"
D
7
PI
15
CL300
LO FB
1"x1/2"
NOTE 7 1/2"
16
+
1/2"
VI
17
PZV 0076
3/4"
CL300
1/2"
VI
1/2"
+
LO FB
18
+
PZV 0065
3/4"
CL300
LO FB
1"x1/2"
11
1/2"
+
VENDOR TRJR
1"D1" 56.30
+
PZV 0037
3/4"
+
NOTE 12,17
1"D1" 56.30
+
PZV 0036
3/4"
NOTE 12,17
19
2"-CHP-011053001-103SC1P-N
D
21 20
1/2"-CHP-011053407-106SC1P-N
20 19
23
1/2"-CHP-011053411-101SC1P-N
D
1"-CHP-011053003-106SC1P-N
24
1"x1/2"
1/2"-CHP-011053407-106SC1P-N
NOTE 10
1"-CHP-011053002-106SC1P-N
2"-CHP-011053403-101SC1P-N
25
106SC1P 103SC1P
1/2"-CHP-011053401-101SC1P-N
26
NOTE 8
TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
mm mm barg °C barg °C
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
011-D-0031 VERTICAL 2500.0 2400.0 ATM 47.00 3.50 80.00
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). POS. DESCRIPTION 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAIN SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER NOTES 4 POTABLE WATER 1,2,3,4 DELETED. 5 DEMI WATER 5- FILLING FROM EXTERNAL TANK. FOR FLEXIBLE HOSE CONNECTION. 6 N.A. 6- LEVEL GAUGE MAGNETIC TYPE SHALL BE READABLE FROM FILLING CHEMICAL VALVES. 7 N.A. 7- VISUAL INDICATOR FOR LOCAL DIAPHRAGM FAILURE. INTEGRAL WITH PUMP. NO TAG NUMBER REQUIRED. 8 N.A. 8- OPERATING AND DESIGN CONDITION ACCORDING TO TYPICAL TRANSFER PUMPS FROM SUPPLER. 9 HP STEAM 9- DRIP PAN IS FOR LEAKAGE ONLY. 10- CALIBRATE LEVEL IN VOLUM. 10 MP STEAM 11- TOP OF STEEL OF PACKAGE BASEPLATE. 11 LP STEAM 12- PZV INSTALLED AT LOWER LEVEL THAN THE PZV BLOW-DOWN NOZZLE "A", PZV DISCHARGE PIPE TO BE DRAINED PRIOR TO PZV REMOVAL FOR MAINTE NANCE. 12 HP CONDENSATE 13- ROUTED DIRECTLY TO CURB/PIT AREA IN A SAFE LOCATION. 13 MP CONDENSATE 14- VALVE PIT REFER DWG: SA-JER-DS011-TRJR-194707 AND SA-JER-DSAAA-TRJR-214014. 14 LP CONDENSATE 15- FOR NOZZLE DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE VENDOR DRAWING SA-JER-DS011-DSBU-480125. 15 BFW 16- CATH BASIN REFER TO DWG: SA-JER-DS011-TRJR-194706 AND SA-JER-DSAAA-TRJR-214008. 17- THE PZV SIZE IS 0,56 D. 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MRM / FCB
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 DEMULSIFIER INJECTION PACKAGE
011-074 011-076 Item Tags :
011-075 011-080
011-X-0003
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
011-D-0031
011-G-0030-A/B
011-G-0031-A/B
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480125 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480125 2271-011-PID-0021-053
REV: 05
Sheet: 1 of 1
SCALE: NONE Format:
A1
41
41
011-D-0032 NEUTRALIZING AGENT INJECTION DRUM
011-X-0004 NEUTRALIZING AGENT INJECTION PACKAGE
40 39
40 39
INSULATION: N
NOTE 16 2"-GAS-011054301-101SC1P-N
38
V A1
A2
L3
L2
35
PIPING INST.
34
2" L1A
33
CL300
MAG LG 0112
32 31
6" ID
NOTE 8
30
H
35 34 33
2" L1B
INST. PIPING
NOTE 12
CL300
29
INST.
B
2"
655mm
2"-CHP-011054417-101SC1P-N
CL300
D
PIPING
28 27
36
CL300 2"x1"
CL300
NOTES 7,10,16,19,8
CL300 NC
2"x1/2" 1/2"
1/2"
NOTE 13
1/2"
VENDOR TRJR
32
INSTRUMENT AIR SUPPLY
1"
CBY INSTRUMENT
CL150
31 30 29 28
1/2"-CHP-011054414-101SC1P-N
27
1/2"
1/2"
1"-CHP-011054424-101SC1P-N
23
AY 0017
21
26
1/2"-CHP-011054413-101SC1P-N 1"-CHP-011054423-101SC1P-N 1"D1" 10.90
NOTE 14
VENDOR 1/2"-CHP-011054412-101SC1P-N 1"-CHP-011054420-101SC1P-N NOTE 14 1"D1" 10.90 NOTE 20 FB LO PZV 0067 3/4" D 1/2" D 1"x3/4"
+
FB LO
NOTE 20
PZV 0066 +
3/4" D
1/2" D
AY
NOTE 9
VI
AY
1/2"
0017 A
25
2"x1" 24 23 22
PI 0375
+
1"x3/4"
20
TRJR
+
1/2 "
24
1/2" D
1/2 "
1/2"-CHP-011054413-101SC1P-N
25
1/2"-CHP-011054414-101SC1P-N
26
PI
NOTE 9
VI
0017 B
21 20
1/2"
0374
19
1/2" D
011-G-0032-A
1/2"
1/2"-CHP-011054413-101SC1P-N
14 13 12
NOTE 14
1"D1" 12.00
FB LO 1/2" D
14
1"x3/4"
0255 NOTE 9
1/2" D
3/4" D
PI
PI 0257
1/2"
1/2" D
VI
10
NOTE 1 1/2" D
011-G-0033-A
11
1/2" PIPING INST.
D
1/2"
NOTE 1
12
NOTE 9
AY 0019 B
PIPING INST.
9
13
1"x3/4"
VI
1/2" D
10
15
+
3/4" D
11
16
NOTE 20
PZV 0042
+
AY 0019 A
2"x1"
+
NOTE 20
PZV 0040
17
1"D1" 12.00
NOTE 14
+
FB LO
1/2"
1/2"-CHP-011054411-101SC1P-N 1"-CHP-011054422-101SC1P-N
1"-CHP-011054421-101SC1P-N
1/2 "
15
1/2"-CHP-011054413-101SC1P-N
1/2"-CHP-011054414-101SC1P-N
16
18
D
011-G-0032-B
AY 0019
17
PIPING INST.
NOTE 1
D
D
1/2"
9
011-G-0033-B
1/2"-CHP-011054413-101SC1P-N
AY
8
0021 1/2"-CHP-011054410-101SC1P-N 1"-CHP-011054424-101SC1P-N
1"-CHP-011054419-101SC1P-N 1"D1" 10.60
NOTE 14
6
FB LO
5
NOTE 14
+
1"D1" 10.60
NOTE 20 FB LO
PZV 0041
PZV 0043
+
+
1/2" D
3/4" D
4
3/4" D
1/2" D
1/2 "
1/2 "
AY 0021 A
2
1/2"
1/2"
PI 0256
NOTE 9
1/2"
D
011-G-0034-A ZC
NOTE 15
NOTE 15
SIGNAL FROM 011-AC-0017
SIGNAL FROM 011-AC-0019
DS011-TRJR-480088
DS011-TRJR-480046
3855
3857
0101
NOTES 11,16
1/2"
M
D
VI
0021 B
1/2" D
PIPING INST. 1/2"
M
011-G-0034-B MG
UC
ZC
0032 A
0320
0101
NOTE 17
MCC
BY CIVIL
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
m³/h barg barg barg °C kg/m³
UC
0032 B
0320
DS011-TRJR-480023 3859
011-G-0034-A / B METERING 0.0 01 7.40
011-G-0033-A / B METERING 0.0 04 8.10
011-G-0032-A / B METERING 0.0 01 6.20
10.60 47.00 1000.0
12.00 47.00 1000.0
10.90 47.00 1000.0
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
NEUTRALIZING AGENT TO 011-C-0001 OVERHEAD DS011-TRJR-480020 3133
NEUTRALIZING AGENT TO 011-C-0002 OVERHEAD DS011-TRJR-480043 3252
NOTE 15
OLW
011-D-0032 VERTICAL 1250.0 950.0 ATM 47.00 3.50 80.00
mm mm barg °C barg °C
MG
SIGNAL FROM 011-AC-0021
GENERAL NOTES
TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
D
NOTE 1 TYP. 3
NC NOTE 18
011-G-0034-A / B
6 5
011-G-0033-A NEUTRALIZING INJECTION PUMP (TO 011-C-0001 OVERHEAD)
4
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAIN SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER 5- INSTRUMENT CERTIFICATES SHALL BE AT LEAST EExd IIC T6. 4 POTABLE WATER NOTES 5 DEMI WATER 2,3,4,5,6 DELETED. 1- TRIPLE HEAD DOSING PUMP. 6 N.A. 7- FILLING FROM EXTERNAL TANK. 7 N.A. 8- LEVEL GAUGE MAGNETIC TYPE SHALL BE REDABLE FROM FILLING CHEMICAL VALUES. 8 N.A. 9- VISUAL INDICATOR FOR LOCAL DIAPHRAGM FAILURE. INTEGRAL WITH PUMP. NO TAG NUMBER REQUIRED. 9 HP STEAM 10- OPERATING AND DESIGN CONDITION ACCORDING TO TYPICAL TRANSFER PUMPS FROM SUPPLIER. 10 MP STEAM 11- DRIP PAN IS FOR LEAKAGE ONLY. 12- CALIBRATE LEVEL IN VOLUM. 11 LP STEAM 13- TOP OF STEEL OF PACKAGE BASEPLATE. 12 HP CONDENSATE 14- PZV INSTALLED AT LOWER LEVEL THAN THE PZV BLOW-DOWN NOZZLE "A2". PZV DISCHARGE PIPE TO BE DRAINED PRIOR TO PZV REMOVAL FOR MAINTENANCE. 13 MP CONDENSATE 15- NR. 2 SIGNALS EACH PUMP. TYPICAL. 14 LP CONDENSATE 16- ROUTED DIRECTLY TO CURB/PIT AREA IN A SAFE LOCATION. 15 BFW 17- VALVE PIT REFER DWG: SA-JER-DS011-TRJR-194707 AND SA-JER-DSAAA-TRJR-214014. 18- CATH BASIN REFER TO DWG: SA-JER-DS011-TRJR-194706 AND SA-JER-DSAAA-TRJR-214008. 16 PLANT AIR 19- CHECK VALVE TO BE SUPPLIED BY TRJR. 17 INSTRUMENT AIR 20- THE PZV SIZE 0,56 D. 18 N.A.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
2 1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MRM / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MRM / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION REF. DWG POS.
011-G-0034-A NEUTRALIZING INJECTION PUMP (TO 011-C-0001 OVERHEAD)
NEUTRALIZING AGENT TO 011-C-0003 OVERHEAD DS011-TRJR-480080 3315
1/2"
1/2"
1/2"
NOTE 1 TYP. 3
MCC
011-G-0032-A NEUTRALIZING INJECTION PUMP (TO 011-C-0001 OVERHEAD)
NOTE 9
PIPING INST.
1
7
3
AY
VI 1/2"
2"-CHP-011054417-101SC1P-N
PI 0258
1"x3/4"
1"x3/4"
3
2"x1"
NOTE 20
+
2"-CHP-011054002-101SC1P-N
7
8
2"-CHP-011054003-101SC1P-N
NOTE 1
1/2" D 18
19
PIPING INST.
2"-CHP-011054001-101SC1P-N
22
37
1/2 "
36
CL300
1"-CHP-011054419-101SC1P-N
2"-CHP-011054416-101SC1P-N
011-X-0004
NOTE 14 CL300 2"x1/2"
1/2"-CHP-011054418-101SC1P-N
37
38
011-D-0032
CL300
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 NEUTRALIZING AGENT INJECTION PACKAGE
011-074 011-076 Item Tags :
011-075 011-080
011-X-0004, 011-D-0032, 011-G-0032 A/B, 011-G-0033 A/B, 011-G-0034 A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480126 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480126 2271-011-PID-0021-054
REV: 05
Sheet: 1 of 3
SCALE: NONE Format:
A1
41
41
011-X-0005 CORROSION INHIBITOR INJECTION PACKAGE
40
011-D-0033 CORROSION INHIBITOR DRUM NOTE 15
2"-GAS-011054302-101SC1P-N
39 38
011-X-0005
40 39 38
2" V1
37
2"-CHP-011054725-101SC1P-N
NOTE 15, 18
CL300 2"x1" A2
A1
2" CL300
NOTE 7
36
CL300
L3 35
2" CL300 2"x1/2" 1/2"-CHP-011054726-101SC1P-N
36
2"
35
L2
2" 3/4"
PIPING
34
37
1"-CHP-011054727-101SC1P-N
2"
INST.
34
011-D-0033
L1A CL300
33
33
MAG LG
6" ID
0111 NOTE 8 INST. PIPING
30 29
NOTE 12
2"
1"x1/2"
1/2"-CHP-011054722-101SC1P-N
32
2"x1"
31
2"-CHP-011054702-101SC1P-N
L1B
30
CL300
B1
3/4" INST.
PIPING
28
D1 CL300 2"
2"
CL300
NC
1/2"
1/2"-CHP-011054720-101SC1P-N
2"x1/2" 1"-CHP-011054727-101SC1P-N
27
2"-CHP-011054724-101SC1P-N 1/2"-CHP-011054720-101SC1P-N
26
1/2"
25
D
29
1/2"-CHP-011054722-101SC1P-N
31
VENDOR TRJR
H
655 mm NOTE 13
32
28 27 26 25
1/2"-CHP-011054720-101SC1P-N
24
24
NOTE 14
22
18 17
1"-CHP-011054727-101SC1P-N
19
1/2"-CHP-011054720-101SC1P-N
1/2"-CHP-011054723-101SC1P-N
20
+
1"-CHP-011054727-101SC1P-N
1/2"
VI
1/2"
011-G-0036-A
D
1/2"
VI
1/2" 21 20
1/2"
1/2"
19
1/2"
011-G-0036-B
INST.
1/2"
D
22
1"x1/2"
0339 PIPING
1/2" 1/2" NOTE 1
PI
23
CL300
NOTE 9 1/2"
NOTE 19
+
+
LO FB
1"x1/2"
1/2"-CHP-011054720-101SC1P-N
1/2"
16
1/2"
1"D1" 11.40 PZV 0060
3/4"
CL300
LO FB
NOTE 9
NOTE 14
+
PZV 0058
3/4" 21
NOTE 19
1"D1" 11.40
1/2"
D
0341 PIPING
1/2" NOTE 1
1/2"
18
PI
17
INST.
D
1"-CHP-011054727-101SC1P-N
15
VENDOR
TRJR
1/2"-CHP-011054720-101SC1P-N
14 13 12
NOTE 14
11
8
2"-CHP-011054701-101SC1P-N
+
15 14 13 12 11
+
1/2" 10
CL300
LO FB
1"x1/2"
1"x1/2"
1/2"
VI
NOTE 9
1/2"
2"x1"
1"X1" 10.30 PZV 0061
3/4"
CL300
LO FB
9
NOTE 14
+
+
1"-CHP-011054727-101SC1P-N
10
1"X1" 10.30 PZV 0059
3/4"
1"x1/2"
1/2"-CHP-011054721-101SC1P-N
1/2"-CHP-011054721-101SC1P-N
16
2"-CHP-011054702-101SC1P-N
23
8
1/2"
VI
NOTE 9
9
7
7
011-G-0035-A
1/2"
1/2"
PI
6
011-G-0035-B
1/2"
1/2"
PI
0340 1/2"
5
1/2"
D
PIPING
1/2"
M
NOTE 1
1/2"
D
6
0342
INST.
1/2" 1/2"
D
PIPING
1/2"
M
NOTE 1
1/2"
INST.
5
D
4
4
TYP. 3
TYP. 3 3
2"-CHP-011054724-101SC1P-N
ZC 0101
MCC
MG 0035 A
ZC 0101
MG 0035 B
MCC
2
CORROSION INHIBITOR TO 011-C-0001 OVERHEAD
CORROSION INHIBITOR TO 011-C-0002 OVERHEAD
DS011-TRJR-480020 3124
DS011-TRJR-480043 3132
3 2
1
1
NOTES 11,15
NOTE 17
BY CIVIL
NC NOTE 16
OLW
011-G-0036-A/ B CORROSION INHIBITOR INJECTION PUMPS (TO 011-C-0002)
011-G-0035-A/ B CORROSION INHIBITOR INJECTION PUMPS (TO 011-C-0001)
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR/ STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT/ STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JVM / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MRM / FCB
RDP / MAC
JAL
REV
GENERAL NOTES
DRUM TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
011-D-0033 VERTICAL 1250.0 950.0 ATM 47.00 3.50 80.00
mm mm barg °C barg °C
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
m³/h barg bar barg °C kg/m³
011-G-0035-A / B METERING 0.0 01 7.50 NOTE 10 10.30 47.00 1000.0
011-G-0036-A / B METERING 0.0 03 8.50 NOTE 10 11.40 47.00 1000.0
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAIN SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER NOTES 4 POTABLE WATER 2,3,4,5,6 DELETED. 5 DEMI WATER 1- DOUBLE HEAD DOVING PUMP. 6 N.A. 7- FILLING FROM EXTERNAL TANK. 7 8- LEVEL GAUGE MAGNETIC TYPE SHALL BE READABLE FROM FILLING CHEMICAL VALVES. N.A. 9- VISUAL INDICATOR FOR LOCAL DIAPHRAGM FAILURE. INTEGRAL WITH PUMP.NO TAG NUMBER REQUIRED. 8 N.A. 10- OPERATING AND DESIGN CONDITION ACCORDING TO TYPICAL TRANSFER PUMPS FROM SUPPLIER. 9 HP STEAM 11- DRIP PAN IS FOR LEAKAGE ONLY. 10 MP STEAM 12- CALIBRATE LEVEL IN VOLUM. 11 LP STEAM 13- TOP OF STEEL OF PACKAGE BASEPLATE. 12 HP CONDENSATE 14- PZV INSTALLED AT LOWER LEVEL THAN THE PZW BLOW-DOWN NOZZLE "A2" PZV DISCHARGE PIPE TO BE DRAWED PRIOR TO PZV REMOVAL FOR MAINTENANCE. 13 MP CONDENSATE 15- ROUTED DIRECTLY TO CURB/PIT AREA IN A SAFE LOCATION. 16- CATH BASIN REFER TO DWG: SA-JER-DS011-TRJR-194706 AND SA-JER-DSAAA-TRJR-214008. 14 LP CONDENSATE 17- VALVE PIT REFER DWG: SA-JER-DS011-TRJR-194707 AND SA-JER-DSAAA-TRJR-214014. 15 BFW 18- CHECK VALVE TO BE SUPPLIED BY TRJR. 19-THE PZV SIZE IS 0,56 D. 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A.
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CORROSION INHIBITOR INJECTION PACKAGE ORIGINAL SIGNED IN PROJECT FILE
Item Tags : 011-X-0005
011-075 011-080
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480127 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480127 2271-011-PID-0021-054
REV: 05
Sheet: 2 of 3
SCALE: NONE Format:
A1
41
011-D-0034 PHOSPHATE DRUM
40
MK
39
TYP. 1
41
011-X-0006 PHOSPHATE PACKAGE
40 39
MCC
0005 38
38
011-X-0006
37
37
NOTE 12 2"-GAS-011054303-101SD0P-N
36
36
M
011-MK-0005
35
6" CL150
34
K1
2"-CHP-011054834-101SD0P-N
L3
2"
31
2"
31
LG
011-K-0005
18" ID
0119 NOTE 5
30
M
2" L1B CL300
B1
3/4" INST.
25
PIPING
D1 2" CL300 2" NC
CL300
1"-CHP-011054841-101SD0P-N
MAG
INST. PIPING
33 32
NOTE 14
CL300
26
D
011-D-0034
L1A
29
27
1"-CHP-011054841-101SD0P-N
1"-CHP-011054840-101SD0P-N
INST.
28
3/4"
3/4"
PIPING 30
34
5
A4 2" CL300 2"x1/2" L2 2"
2" CL300
NOTE 4
32
A1
1-1/2"-DWA-011054301-101SR0P-N
6984
1/2"-CHP-011054832-101SD0P-N
NOTES 7,12,16
CL300
35
TRJR
1-1/2"-DWA-011054401-101SR0P-N
665 mm NOTE 10
33
VENDOR
CL300 A2 2"x1-1/2" 2" V A3 NOTE 11 CL300 2"x1"
29 28 27 26 25
2"x1/2"
24
24
VENDOR
23
2"-CHP-011054833-101SD0P-N
NOTE 9
23
1"x1/2"
1/2"-CHP-011054830-101SD0P-N
22
TRJR 1"-CHP-011054801-101SD0P-N
22 21
20
20
1/2"-CHP-011054830-101SD0P-N
21
19
1/2"-CHP-011054831-101SD0P-N 18
1/2" D
17
1/2"-CHP-011054831-101SD0P-N
1/2"-CHP-011054831-101SD0P-N
16 15 14 13 12
NOTE 11
18 17 16 15
NOTE 11 NOTE 17
1"D1" 9.30
19
+
1"D1" 9.30
PZV 0056
PZV 0057
NOTE 17
14
+
13
3/4"
3/4"
1/2"
CL300
LO FB
11
+
+
12
CL300
LO FB
1"x1/2"
1/2"
11
1"x1/2"
10
10
1/2"
9
1"-CHP-011054801-101SD0P-N
1/2"
9 8
VI
NOTE 6
7
NOTE 6 1/2"
0333 PIPING
5
1/2" 1/2"
D
4
NOTE 12
3
1/2"
PI
011-G-0037-A
1/2"
6
VI
011-G-0037-B
1/2"
INST.
PIPING
1/2"
1/2" 1/2"
M TYP. 3
D
1/2"
NOTE 12
PI 0334
D
NOTE 12
INST.
1/2" 1/2"
M
D
8 7 6 5 4
TYP. 3
NOTE 12
3
PHOSPHATE INJECTION TO 011-D-0011
2
ZC
2"-CHP-011054833-101SD0P-N
0101
MCC
MG
ZC
0037 A
0101
MCC
MG
2
DS011-TRJR-480105 3488
0037 B
1
1
NOTES 8,12
NOTE 13
BY CIVIL
NC NOTE 15
OLW
011-K-0005 PHOSPHATE MIXER
011-G-0037-A / B PHOSPHATE PUMPS GENERAL NOTES
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND. MIXERS TYPE POWER SPEED
Kw rpm
m³/h barg bar barg °C kg/m³
011-G-0037-A / B METERING 0.0 012 4.00 9.30 47.00 1000.0 011-K-0005 TURBINE PBT/45 0.37 1500.0
TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
mm mm barg °C barg °C
011-D-0034 VERTICAL 1250.0 950.0 ATM 47.00 7.00 80.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). POS. DESCRIPTION 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAIN SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER NOTES 4 POTABLE WATER 1,2,3 DELETED. 5 DEMI WATER 4- FILLING FROM EXTERNAL TANK. FOR FLEXIBLE HOSE CONNECTION. 6 N.A. 5- LEVEL GAUGE MAGNETIC TYPE SHALL BE READABLE FROM FILLING CHEMICAL VALVES. 7 N.A. 6- VISUAL INDICATOR FOR LOCAL DIAPHRAGM FAILURE. INTEGRAL WITH PUMP. NO TAG NUMBER REQUIRED. 8 N.A. 7- OPERATING AND DESIGN CONDITION ACCORDING TO TYPICAL TRANSFER PUMPS FROM SUPPLER. 9 HP STEAM 8- DRIP PAN IS FOR LEAKAGE ONLY. 10 MP STEAM 9- CALIBRATE LEVEL IN VOLUM. 10- TOP OF STEEL OF PACKAGE BASEPLATE. 11 LP STEAM 11- PZV INSTALLED AT LOWER LEVEL THAN THE PZV BLOW-DOWN NOZZLE "A", PZV DISCHARGE PIPE TO BE DRAINED PRIOR TO PZV REMOVAL FOR MAINTE NANCE. 12 HP CONDENSATE 12- ROUTED DIRECTLY TO DRIP PAN/PIT AREA IN A SAFE LOCATION. 13 MP CONDENSATE 13- VALVE PIT REFER DWG: SA-JER-DS011-TRJR-194707 AND SA-JER-DSAAA-TRJR-214014. 14 LP CONDENSATE 14- FOR NOZZLE DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE VENDOR DRAWING SA-JER-DS011-DSBU-480007. 15 BFW 15- CATH BASIN REFER TO DWG: SA-JER-DS011-TRJR-194706 AND SA-JER-DSAAA-TRJR-214008. 16 PLANT AIR 16- CHECK VALVE TO BE SUPPLIED BY TRJR. 17- THE PZV SIZE IS 0,56 D. 17 INSTRUMENT AIR 18 N.A.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MRM / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PHOSPHATE INJECTION PACKAGE
011-074 011-076 Item Tags :
011-075 011-080
011-X-0006
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
011-D-0034
011-G-0037-A/B
011-K-0005 ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480128.pid
Discipline: PRO
SA-JER-DS011-TRJR-480128 2271-011-PID-0021-054
REV:
05
Sheet: 3 of 3
SCALE: NONE Format:
A1
41
41
PI 0162 LPT
39
BRINE FROM 011-E-0033
38
6"-BRN-011042003-101CS4P-N
INST. PIPING
1"
NOTE 1
INTERCONNECTING
B.L.
40
UNIT 011 V
1"
D NC
39
IP-1311-L BRINE TO WWT UNIT 651 SA-JER-IP691-TPIT-481002
MIN.
DS011-TRJR-480109 3490
40
UNIT 691
MIN.
1"
D NC
37
1"
38 37
36
36
PI 0163
35
P
35
N
34
34
33 SOUR WATER
32 31 30
FROM 011-G-0006
3/4"
LPT
NOTE 1
INST. PIPING
IP-1308-L
8"-AWS-011044002-106CH2S-P
DS011-TRJR-480114 3535
D
MIN.
3/4" 3/4"
SIGNAL TO LY-0067-B
3/4"-AWS-011098001-106CH2S-P 3/4"
3/4" UC MIN.
3794
28 27 26
NON PHENOLIC STRIPPED WATER TO 011-D-0007 DS011-TRJR-480112 3534
3/4"
NOTE 1
6"-STW-011098001-101CS2P-N
INST. PIPING
NOTE 4 0-50%
FT 0194
23
1/2"
PV 0446 A
1/2"
3/4" NC
MIN.
PC
0446
0446
D
D NC
26
STRIPPED WATER FROM SWS UNIT 213 SA-JER-IP691-TPIT-481002
3/4"
25 24 23
SPLIT RANGE
22 21
3"x2"
50-100%
FC
3"-HFO-011098014-103CS1P-N
19
3"x2"
18
NC 2"
MIN.
3"x2"
3/4"-HFO-011098015-103CS1P-N
20 19
3/4"
2"x3/4" D
MIN.
103CS1P 101CH2S
250mm MIN.
18
2"-CLD-011098324-101CH2S-P
17
FT 0122 A
16
H
16
6960 +
MIN. 3/4"
NOTE 6
MIN. 2"x3/4"
D
103CS1P 101CH2S
PT 0446
6
LPT FROM 011-E-0035
3/4"
8"x6"
6"-DIE-011025003-103CS1P-N
3/4"
10
25 4879
DS011-TRJR-480062 3286
9 8
PI 0335
7
103CS1P
INST. LPT
3/4"
103CS1X
6
V 3/4"
PIPING 8"-DIE-011025003-103CS1P-N
3/4"
5
IP-1310-L HAGO+ LVGO TO HP HDS UNIT 091 SA-JER-IP691-TPIT-481002
3/4"
4 3 2
MIN. 3/4"
0445
3/4"-DIE-011098003-103CS1P-N
MIN.
PI 3/4"-HFO-011098008-103CS1P-N
1
3/4" UC
3/4"
2"x3/4"
2"x3/4"
250mm MIN.
MIN.
MIN.
PIPING INST. 3/4"
UC MIN.
6"-HFO-011098005-103CS1P-N
6"-DIE-011098002-103CS1P-N
MIN.
3
12 11
MIN.
HAGO
2"-CLD-011098319-101CH2S-P INST. PIPING
13
HAGO+LVGO TO STORAGE SA-JER-IP691-TPIT-481027
3/4"
8"-DIE-011098006-103CS1P-N
7
IP-1316-L
3/4"-HFO-011098007-103CS1P-N
3/4"-HFO-011098007-103CS1P-N
8
14
8"x6"
NC
9
3/4"
10"-HFO-011099104-103CS1P-H
10
2"
MIN.
3/4"
6"-HFO-011098016-103CS1P-N
FT 0122 B
6"
MIN.
8"x6"
11
V
LPT
10"x8"
FC
1/2" 1/2"
12
3/4"
15
103CS1X
10"-DIE-011098006-103CS1P-H
250mm MIN.
13
8"x6"
NOTE 5
LPT
LPT
INST. PIPING
6" 8"x6"
VDU BY PASS
1/2" 1/2" FI 0122
103CS1P
PV 0446 B
14
17
N
PI 0493
25
15
1
MIN.
2"
3"x2"
FI 0194
PY
3"-HFO-011098014-103CS1P-N
+
20
2
27
IP-1309-L
24
4
28
4874
25
5
250mm MIN. LPT
MIN.
21
29
25
NOTE 2
22
SIGNAL FROM LC UNIT 213
MIN.
106CH2S 101CH2S
2"-CLD-011098326-101CH2S-P
31 30
2"x3/4"
PI 0164
32
SOUR WATER TO SWS UNIT 213 SA-JER-IP691-TPIT-481002
MIN.
D
3/4"
DS011-TRJR-480112
29
33
V 3/4"
103CS1P
2"-CLD-011098317-101CH2S-P LAGO FROM 011-E-0034 DS011-TRJR-480133 3546
HAGO TO DHC / MHC UNIT 041/051 DS011-TRJR-480137 3551
103CS1P 101CH2S
250mm MIN.
101CH2S 6"-DIE-011037007-103CS1P-N 2"-CLD-011098302-101CH2S-P
HAGO
LVGO
4887
25
DS011-TRJR-480098 3474
DS011-TRJR-480136 7800
4884
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 5- IP'S INFORMATION OF TWIN UNIT CAN BE FOUND IN PID SA-JER-DS011-TRJR-480144.
NOTES 3 DELETED 1- VALVE TO BE LOCATED AT MINIMUN DISTANCE FROM B.L. 2- THIS LINE EXISTS ONLY FOR UNIT 011 AND NOT FOR UNIT 012. 4- SPLIT RANGE TO BE OPTIMIZED DURING COMMISSIONING 5- HIGH RANGEABILITY; FT-0122A LOW FLOW RANGE AND FT-0122B HIGH FLOW RANGE 6- BLIND IS TURN TO CLOSE POSITTION DURING VDU BYPASS.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
FROM VACUUM RESIDUE LINE DS011-TRJR-480138 7815
TO SLOP
FROM 011-E-0029
25
ATM RESIDUE
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT/ STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
NPS / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
DESCRIPTION
19 N.A. 20 FUEL OIL 21 FUEL GAS 22 N.A. 23 N.A. 24 N.A. 25 CLOSED DRAIN 26 N.A. 27 L.P. NITROGEN 28 H.P. FLARE 29 L.P. FLARE 30 SOUR/ACID FLARE 31 PILOT GAS 32 AUX COOLING WATER FLO FLUSHING OIL AMD AMINE CLOSED DRAIN CND TURBINE CONDENSATE
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080 011-077 011-079 011-071 011-220
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 B.L. PROCESS No 1
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480132.pid
Discipline: PRO
SA-JER-DS011-TRJR-480132 2271-011-PID-0021-098
REV:
05
Sheet: 1 of 6
SCALE: NONE Format:
A1
41
41
40
40
39
UNIT 011
38
36
PI 0168
TT 0463
35 34 FROM 011-E-0034
35
INST. PIPING
NOTE 4 3/4" LPT
2" LAGO
V
MIN.
DS011-TRJR-480060 3275
33
MIN.
MIN. 3/4"
3/4"
LAGO TO STORAGE UNIT 661 SA-JER-IP691-TPIT-481027
UC
31 30
0460
TT 0460
28 27
2"-CLD-011098307-101CH2S-P NOTE 4 LPT
2"
28
INST. PIPING
3/4"
25
103CS1P 103CS1X V 3/4"
4915
6"-DIE-011025015-103CS1P-N
DS011-TRJR-480060 3282
27
IP-1302-L MIN.
LAGO FROM 011-E-0034
29
PI 0336
250mm MIN.
103CS1P 101CH2S
29
26
LAGO TO LP HDS UNITS 101 SA-JER-IP691-TPIT-481002
MIN.
MIN. 3/4"
MIN.
23
3/4"
24
UC
3/4"-DIE-011098005-103CS1P-N
23
2"x3/4"
SIGNAL
22
TO 011-FY-0119
DS011-TRJR-480060
19
TI 0462
NOTE 4 3/4" LPT
2"
2"-CLD-011098306-101CH2S-P
INST. PIPING
16 15
ZHXS 0046
14
ZC 0401
ZHSR 0046
MIN.
3/4"-JET-011098003-103CS1P-N 2"x3/4"
RESET
0466
10
PT 0428
9 8
3/4"
103CS1P 101CH2S
S
UC IA
CLOSED
OPEN
POSITIONER
BY-PASS
ZLC
ZLO
ZYC
ZHA
0046
0046
0046
0046
2"-CLD-011098311-101CH2S-P MIN.
DE
3/4"
2"-CRU-011098001-103CS1P-N
ATM
ZLS 0046 C
ZLS 0046 O
ZY 0046
ZHS 0046
ZV 0046 +
2"
PI 0174
3/4"
13 12 11
4917
2"-FLO-011098301-101CS1P-N
INST. PIPING
10 FLO
9
103CS1P 101CS1X
MIN.
8
LPT
18"-CRU-011098001-103CS1P-N
7
IP-1314-L TSO FC NOTES 1,2,4,6,7
MIN.
MIN. 3/4"
MIN.
5
103CS1P 101CH2S
4
UC
250mm MIN. MIN.
6"-DIE-011098002-103CS1P-N
6"-DIE-011098009-103CS1P-N
8"-JET-011098001-103CS1P-N
6
2"
2"-CRU-011098003-103CS1P-N
3 2
2"-CLD-011098314-101CH2S-P
1 25 4918
KEROSENE
LAGO
LAGO
TO 011-E-0037A/D
TO 011-E-0037A/D
TO HP HDS UNIT 091
DS011-TRJR-480136 3570
DS011-TRJR-480136 3574
DS011-TRJR-480132 3546
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 5- PI'S INFORMATION OF TWIN UNIT CAN BE FOUND IN PID SA-JER-DS011-TRJR-480144.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JVM / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
IRG / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS.
1 2 3 4 5 NOTES 6 5- DELETED. 7 1- BATTERY LIMIT ZV. 8 2- VALVE TO BE LOCATED AT LEAST 7.5 m BEYOND THE EDGE OF ANY FIRE HAZARDOUS ZONE. 9 3- VALVE TO BE OPENED FOR CDU START UP AND OFF SPEC PRODUCT. 10 4- VALVE TO BE LOCATED AT MINIMUM DISTANCE FROM BL. 11 6- EACH BL EMERGENCY SHUTDOWN VALVE SHALL HAVE A DEDICATED SAFE LOCATION PUSHBUTTON. THE SAFE-LOCATION ACTUATING BUTON SHALL BE GROUPED 12 TOGETHER AND INSTALLED AT GRADE AND LOCATED MORE THAN 15 M FROM ANY FIRE-HAZARDOUS EQUIPMENT OR PROCESS VESSEL. SAFE-LOCATION BUTTONS 13 SHALL ALSO BE AT LEAST 7.5 M BEYOND THE EDGE OF ANY FIRE-HAZARDOUS ZONE. 14 7- DESIGN PRESSURE OF ZV-0046 AN SYSTEM DOWNSTREAM SHALL BE 16.5 barg DUE TO SURGE ANALYSIS. 15 8- 1oo2 VOTING LOGIC BETWEEN SIGNALS ZHXS-0046-A (PIB) AND ZHXS-0046-B (HCB). 16 9- DELETED. 17 18 This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
CRUDE OIL FROM STORAGE UNIT 561 SA-JER-IP691-TPIT-481020
MIN.
2"x3/4"
4
1
15
4920
5
2
16
UC
3/4" D
3/4"
3
3/4"
17
25
MIN.
DS011-TRJR-480001 2659
INST. PIPING
TT 0466
+
KEROSENE TO STORAGE UNIT 661 SA-JER-IP691-TPIT-481026
14
103CS1P 101CS1P
TI
11
ZYV 0046
MIN.
2"-CRU-011098004-103CS1P-N
PI 0428
12
18
MIN.
3/4"
NOTE 8
13
6
IP-1317-L
MIN.
ES
ES
CRUDE OIL TO 011-G-0001
19
MIN.
ZHXS 0046 L
20
250mm MIN.
17
21
3/4"
4916
DS011-TRJR-480058 3264
7
V
25
8"-JET-011025002-103CS1P-N
SIGNAL FROM LP HDS UNIT 101 101-LC-0004 C SA-JER-DS101-TRJR-480043
103CS1P 103CS1X
MIN.
KEROSENE FROM 011-E-0023
250mm MIN.
TT 0462
103CS1P 101CH2S
PI 0171
5406
20
18
25
MIN.
24
21
32
MIN.
MIN.
3/4"-DIE-011098004-103CS1P-N 2"x3/4"
TI
22
34
IP-1315-L
30
25
103CS1P 103CS1X
3/4"
6"-DIE-011025002-103CS1P-N
31
26
38 37
36
32
UNIT 691
B.L.
TI 0463
37
33
39
INTERCONNECTING
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 B.L. PROCESS No 2 ORIGINAL SIGNED IN PROJECT FILE
Item Tags :
011-075 011-080 011-077
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480133.pid
Discipline: PRO
SA-JER-DS011-TRJR-480133 2271-011-PID-0021-098
REV:
05
Sheet: 2 of 6
SCALE: NONE Format:
A1
41
41
ZHXS 0120 L
40
ES
ZC 0408
ZHSR 0120
39
ZYV 0120 +
38
TI 0445
S
RESET 40
CLOSED
OPEN
POSITIONER
BY-PASS
39
ZLC 0120
ZLO 0120
ZYC 0120
ZHA 0120
38
IA
37
37
DE
36
ATM
TT
35
ZLS 0120 C
0445
ZLS 0120 O
ZY 0120
PI 0372
ZHS 0120
ZV 0120 +
3/4"
34
FC TSO NOTES 1,2,3,6,7
MIN.
MIN.
DS011-TRJR-480001 2677
SLOP FROM STORAGE UNIT 681 SA-JER-IP691-TPIT-481021
3/4"
3/4"
33 32
MIN. ZHXS 0121 L
30
NOTE 9 29
ZHXS
PI 0427
28 27
ES
ES
ZC
ZHSR
0403
0121
RESET
ZYV 0121 +
S
IA
CLOSED
OPEN
POSITIONER
BY-PASS
ZLC 0121
ZLO 0121
ZYC 0121
ZHA 0121
0427
PI 0166
3/4"
ATM
INST. PIPING
0121 C
ZY
0121 O
28 27
2"-CLD-011098316-101CH2S-P
26 25
ZHS
0121
0121 3/4"
25
INST. PIPING
UNIT 111
4905
24
UNIT 011 UNIT 111
+
3/4"
LPT
23
14"-HFO-111011001-103CL2P-H
14"-HFO-011098001-103CL2P-H
MIN.
TO 011-E-0022
ZLS
ZV 0121
3/4" HAGO PA
ZLS
29
UC
103CS1P 101CH2S
DE
26
24
3/4"
2"x3/4"
PT
25
30
MIN.
0121 L
31
3/4"-SLP-011098004-103CS1P-N
MIN.
31
22
LPT IP-1312-L
32
23
35
103CS1P 103CS1X
2"
6"-SLP-011098002-103CS1P-N
36
INTERCONNECTING
250mm MIN.
33
SLOP TO 011-G-0001
INST. PIPING
MIN.
34
UNIT 011 UNIT 691 B.L.
FC TSO NOTES 1,2,3,6
DS011-TRJR-480052 3259
21
INST. PIPING 3/4" 3/4"
NOTE 4
MIN.
12"-HFO-011098011-103CL2P-H
HAGO PA FROM NAPHTHA SPLITTER REBOILER IN NHDT UNIT-111 DS111-TRJR-480043
22 21
2"
MIN.
20
20
2"-HFO-011098009-103CL2P-P
19
MIN. MIN. +
16
PDC 0384
12"x8"
17
10"
FO
8"
12"x10"
12"x8"
15
3/4"-HFO-011098013-103CL2P-P
2"-CLD-011098321-101CH2S-P
INST. PIPING 3/4" 3/4"
12
0467
PI 0167
14"-HFO-011027003-103CL2P-H
14
25
25
13
5427
TT 0467
3/4"
2"
INST. PIPING
12
V
3/4"
2" 11
NOTE 3
14"-HFO-111018004-103CL2P-H
MIN.
FROM 011-G-0012
15
4908
LPT HAGO PA
16
2"-CLD-011098304-101CH2S-P
TI
3/4"
13
10
2"x3/4"
3/4"
14
11
103CL2P 101CH2S
250mm MIN.
PDT 0384
12"x10"
18
MIN.
UC
PDV 0384
17
250 mm
103CL2P 101CH2S
18
19
2"
DS011-TRJR-480065 3288
NOTE 4
MIN.
9
9
MIN.
2"
8
10
HAGO PA TO NAPHTHA SPLITTER REBOILER IN NHDT UNIT-111 DS111-TRJR-480042
8
2"-HFO-011098010-103CL2P-P
MIN.
7
2"
7
MIN.
UC 6 5
5
250mm MIN.
103CL2P 101CH2S
4
6
2"-CLD-011098305-101CH2S-P
3
4 3
25 4910
2
2
1
1
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 5- IP´S INFORMATION OF TWIN UNIT CAN BE FOUND IN PID SA-JER-DSO11-TRJR-480144.
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
VJS / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS.
1 2 3 4 NOTES 5 6 5,8 DELETED. 1- BATTERY LIMIT ZV. 7 2- VALVE TO BE LOCATED AT LEAST 7.5 m BEYOND THE EDGE OF ANY FIRE HAZARDOUS ZONE. 8 3- VALVE TO BE LOCATED AT MINIMUM DISTANCE FROM BL. 9 4- DEDICATED INTERCONNECTING PIPERACK BETWEEN UNITS 011 AND 111. 10 6- EACH BL EMERGENCY SHUTDOWN VALVE SHALL HAVE A DEDICATED SAFE LOCATION PUSHBUTTON. THE SAFE-LOCATION ACTUATING BUTON SHALL BE GROUPED TOGETHER AND INSTALLED AT GRADE AND LOCATED MORE THAN 15 M FROM ANY FIRE-HAZARDOUS EQUIPMENT OR PROCESS VESSEL. SAFE-LOCATION BUTTONS 11 12 SHALL ALSO BE AT LEAST 7.5 M BEYOND THE EDGE OF ANY FIRE-HAZARDOUS ZONE. 7- DESIGN PRESSURE OF ZV-0120 AND SYSTEM DOWNSTREAM SHALL BE 30 BARG DUE TO SURGE ANALYSIS. 13 9- 1oo2D VOTING LOGIC BETWEEN SIGNALS ZHXS-0121-A (PIB) AND ZHXS-0121-B (MCB). 14 15 16 17 18 This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 Item Tags :
011-075 011-080
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 B.L. PROCESS No 3 ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480134.pid
Discipline: PRO
SA-JER-DS011-TRJR-480134 2271-011-PID-0021-098
REV:
05
Sheet: 3 of 6
SCALE: NONE Format:
A1
41
41
INTERCONNECTING SIGNAL
40
40
FROM FC-0118 (PV)
DS011-TRJR-480058
39
PI 0447
38
36
PHENOLIC STRIPPED SOUR WATER TO 011-D-0007
6"-STW-011098002-101CS2P-N
INST. PIPING
3/4"
NOTE 3
SIGNAL 101-FY-0074 TO LP HDS UNIT 101 DS101-TRJR-480043
UNIT 691
39
UC
38
V
3/4"
3/4"
37
LPT IP-1332-L
DS011-TRJR-480112 3533
MIN.
37
UNIT 011 B.L.
6868
3/4"
D
3/4"-STW-011098003-101CS2P-N
35
B.L.
NC 101CS2P 101CS1P
34
MIN.
36
STRIPPED WATER FROM UNIT 211 (PHENOLIC SWS) SA-JER-IP691-TPIT-481002
MIN.
35 34
33
33
3/4"-OLW-011098301-101CS1P-N 32
32
TO GROUND 31 30
31
FROM FC-0144 (PV)
30
DS011-TRJR-480098 6967
NOTE 3 LPT KEROSENE FROM 011-E-0001
103CS1P
PI 0337
28
3/4"
103CS1X SIGNAL 091-FI-0075 TO HP HDS UNIT 091 DS091-TRJR-480048
29 28
INST. PIPING
V
3/4"
27
IP-1301-L
8"-JET-011025001-103CS1P-H
DS011-TRJR-480058 3266
MIN.
26
UNIT 691
SIGNAL
29
27
UNIT 011
25
26
KEROSENE TO LP HDS UNIT 101 SA-JER-IP691-TPIT-481002
MIN.
3/4"
25
MIN. 24
24
MIN. 3/4"
23
UC
23
MIN.
3/4"-JET-011098002-103CS1P-P 2"x3/4"
22 21
21
250mm MIN.
103CS1P 101CH2S
20
2"-CLD-011098310-101CH2S-P 19 18
22
20 19 18
25 4926
17 16 15 14 13 12
17 SIGNAL
16
FROM FC-0120 (PV)
DS011-TRJR-480062
15
SIGNAL 091-FI-0074 TO HP HDS UNIT 091 DS091-TRJR-480048
6975
14
SIGNAL TO FY-0118
DS011-TRJR-480058
13
SIGNAL 101-LC-0004B FROM LP HDS UNIT 101 DS101-TRJR-480043
3789 SIGNAL
12
FROM FC-0119
DS011-TRJR-480060
10
FI 0017
9
TI
7
INST. PIPING
6 5 4 3
1/2"
+
ZHSR 0045
S
9
CLOSED
OPEN
BY-PASS
ZLC
ZLO
ZHA
0045
0045
UNIT 011 BL
PI
0045
2"
ZV 0045 +
4"x3"
8
UNIT 691
0173
7
103CH2S 103CH1SX
DE
1/2"
10
RESET
IA
3/4"-NAP-011098005-103CH2S-P 3"-NAP-011098001-103CH2S-P
ZYV 0045
NOTE 7
TT 0470
NOTE 6 TYPE 13 SC 011-SC-0039
ZC 0400
ES
0470
8
FT 0017
SIGNAL 101-FY-0075 TO LP HDS UNIT 101 DS101-TRJR-480043
ZHXS 0045 L ZHXS 0045
WILD NAPHTHA TO 011-C-0002
11
ES
6970
ATM
ZLS 0045 C
ZLS 0045 O
4"x3"
ZHS 0045
6
INST. PIPING 3/4"
5
LPT IP-1305-L
FC TSO
DS011-TRJR-480043 3231
MIN.
11
4
WILD NAPHTHA FROM HP HDS UNIT 091 SA-JER-IP691-TPIT-481002
MIN. 3/4"
NOTES 1,2,3,5
3
MIN.
2
2
MIN.
1
3/4"
UC
3/4"-NAP-011098007-103CH2S-P
3"-NAP-011098002-103CH2S-P
MIN.
WILD NAPHTHA TO 011-C-0001
2"x3/4"
DS011-TRJR-480020 3112
103CH2S 101CH2S
2"-CLD-011098313-101CH2S-P
250mm MIN.
1
25 4928
GENERAL NOTES
POS. 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 5- IP'S INFORMATION OF TWIN UNIT CAN BE FOUND IN PID SA-JER-DS011-TRJR-480144. 4 NOTES 5 4- DELETED. 6 1- BATTERY LIMIT ZV. 2- VALVE TO BE LOCATED AT LEAST 7.5m BEYOND THE EDGE OF ANY FIRE HAZARDOUS ZONE. 7 3- VALVE TO BE LOCATED AT MINIMUN DISTANCE FROM BL. 8 5- EACH BL EMERGENCY SHUTDOWN VALVE SHALL HAVE A DEDICATED SAFE LOCATION PUSHBUTTON. THE SAFE-LOCATION ACTUATING BUTON SHALL BE GROUPED TOGETHER AND INSTALLED AT GRADE AND LOCATED MORE THAN 15 M FROM ANY FIRE-HAZARDOUS EQUIPMENT OR PROCESS VESSEL. SAFE-LOCATION BUTTONS 9 10 SHALL ALSO BE AT LEAST 7.5 M BEYOND THE EDGE OF ANY FIRE-HAZARDOUS ZONE. 6- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS011-TRJR-480274. 11 7- 1oo2D VOTING LOGIC BETWEEN SIGNALS ZHXS-0045A (PIB) AND ZHXS-0045B (MCB). 12 13 14 15 16 17 18 This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JCP / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
DATE
UTILITIES IDENTIFICATION DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 B.L. PROCESS No 4 ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480135.pid
Discipline: PRO
SA-JER-DS011-TRJR-480135 2271-011-PID-0021-098
REV:
05
Sheet: 4 of 6
SCALE: NONE Format:
A1
011-E-0037-A / C / B / D SLOP COOLER
NOTE 12
12"-SLP-011098019-103CS1P-H
SLOP DS011-TRJR-480219 3597
0464
0464
DS011-TRJR-480232 3584
6"-HFO-011025002-103CS1P-N
DS011-TRJR-480062 3285
8"
HAGO
2"-SLP-011098019-103CS1P-P
28
HV 0018
TI 0449
D
3/4"
3
+
23
MIN. 14"-CWR-011098001-103CS1P-N
101CS1P 103CS1P
1"D2" 23.00
24
6"-SLP-011099001-103CS1P-S
18"x12" 18"-CWR-011098001-103CS1P-N FL
4677
25
3/4"
FT
TT 0449
18"x14" 18"x14"
NC
2"
CL600
3"-CWR-011098006-101CS1P-N
3"x2"
MIN.
+
1"D2" 23.00
21
2"x1"
MIN.
20
14"-CWR-011098001-103CS1P-N
3/4"
TZV 0016 +
V
FB LO NOTE 7
16"x14"
16"x14"
V
2"-CWR-011098002-103CS1P-N 3/4" D
3/4"
17
D 16
0461
V
2"
15
TI 0065
2"
TI T2
14" 14"
011-E-0037-A
3/4"
8"
2"
14" 14"
S3
25 24
103CS1P 101CH2S 2"-CLD-011098315-101CH2S-P
23 22 21
25 4934
20
8"x6" NOTE 1
FB LO
D
NOTE 2 17
3/4" D
NOTE 1
011-E-0037-C
NOTE 2
NNF 3/4"
16 15
8"-JET-011098004-103CS1P-S
S1
D
S3
T3
19 18
NOTE 7 NOTE 4
V
D
6"-DIE-011098010-103CS1P-S
2"-CWR-011098004-103CS1P-N
T2
T3
3"x2" 3"-CWR-011098005-101CS1P-N
2"
S1
14
D
2"x1" 3/4"
NOTE 4
18
MIN.
+
27
UC
2"-SLP-011098005-103CS1P-S
4"
28
26
2" MIN.
29
SLOP & CDU/VDU LONG RECIRCULATION UNIT 661 SA-JER-IP691-TPIT-481021
MIN.
8"
1/2" 1/2"
30
2" IP-1313-L
8"
2"
MIN.
TZV 0015
CL600
0162
INST. PIPING
3/4" D
2"
V
6"
MIN.
12" 18"-CWR-011098301-101CS1P-N 18"x12"
NOTE 9
3/4"
6"
MIN.
+
27
16"x6" 3/4" 16"
31
16"-SLP-011098001-103CS1P-S INST. PIPING 3/4" NOTE 3
MIN.
7798
FI 0162
D
32
103CS1X
250mm MIN.
FLO
3/4"
3/4"
D
103CS1P
MIN.
HC 0018
TT 0450
6"-HFO-011098012-103CS1P-S
2"-FLO-011098302-101CS1P-N
D
D
MIN.
29
19
34 33
PI 0321
MIN.
NOTE 1
DS011-TRJR-480138 8303
22
B.L.
ZC 0360
103CH2S 103CS1P
NOTE 1
MIN.
8"-HFO-011099003-103CS1P-S
103CH2S 103CS1P
103CH2S 103CS1P
SLOP
26
TI 0450
NNF 3/4"
101CS1P 103CS1P
30
3/4"
35
UNIT 691
MIN.
DS011-TRJR-480132 7800
32 31
INTERCONNECTING UNIT 011 HH
6"-HFO-011098016-103CS1P-N
FROM 011-E-0035
NOTE 2
MIN. NOTE 2
37 36
NNF
33
TT
NOTE 11
34
TI
2" HAGO FROM 011-E-0035
35
38
FROM 011-D-0014
8"-NAP-011098008-103CS1P-S
36
39
SLOP
4"-SLP-011078001-103CH2S-P
MIN.
37
DS011-TRJR-480140 3599
6"-SLP-011076001-103CH2S-P
FROM 011-D-0018
40
FROM HEADER
TRIM: SLP-011098602-106CS1P/ CWS-011098601-103CS1P INSULATION ( SHELL/TUBE ): H / N
39 38
NAPHTHA
8"-NAP-011098003-103CH2S-N
103CH2S 103CS1P
40
41
START-UP RECIRCULATION LINE TO DISCHARGE 011-G-0001 CRUDE DS011-TRJR-480002 7716
MIN.
41
NNF 3/4"
14
13
13
2"-SLP-011098017-103CS1P-S
0033
UC
16"x14"
0040
101CS1P AG 301FE0W UG
18"x14" 16"-SLP-011098001-103CS1P-S
18"-CWS-011072302-301FE0W-N
2"-SLP-011098013-103CS1P-S
MIN.
2"
2"
D
UC
D
2"-SLP-011098011-103CS1P-S
2"
CL600
UC
MIN.
3/4" D
MIN.
MIN.
1
TI
LPT
MIN.
MIN.
18"x14"
2
2"
14"-CWS-011098003-101CS1P-N
3/4" D
NNF
TT
250mm MIN.
250mm MIN.
2"-CLD-011098323-101CH2S-P
2"-CLD-011098320-101CH2S-P
3
25
25
4678
5433
2550
TI
H
FROM 011-E-0023
DS011-TRJR-480103 7802
DS011-TRJR-480133 3570
GENERAL NOTES
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-E-0037-A / C/ B / D AES 7.00 6.00 82.00 36.50 50.00 46.50 NOTE 10 30.00 23.00 300.00 80.00 2186.0 12.02
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
KEROSENE
FROM 011-G-0018 A/B
0050
8"-SLP-011098010-103CS1P-S
8 7
V 3/4"
3/4"
6
8"-SLP-011098003-103CS1P-S
VACUUM RESIDUE
103CS1P 101CH2S
PI 0496
NOTE 3
0050 103CS1P 101CH2S
103CS1X 9
MIN.
4
D
2" 2"-SLP-011098018-103CS1P-S 103CS1P 101CH2S
NOTE 2
103CS1P 103CH2S
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / FBL
RDP / MAC
JAL
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JVM / FCB
RDP / MAC
JAL
PREPARED BY
CHECKED BY
FROM 011-E-0034
FROM 011-G-0020
FROM 011-E-0029
00
DS011-TRJR-480138 3604
DS011-TRJR-480133 3574
DS011-TRJR-480087 3428
DS011-TRJR-480138 3605
REV
DATE
UTILITIES IDENTIFICATION
011-071 011-071 011-071 011-071 011-071 011-074 011-074
N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
1
13-MAR-2013
FROM HEADER
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
2
2"-CLD-011098325-101CH2S-P
05
LVGO
DESCRIPTION
3
25
RECOVERED OIL
REF. DWG POS.
UC
6978
LAGO
011-073 011-072 011-073 011-071
5
SLOPE TO UNIT 681 SA-JER-IP691-TPIT-481021
2"
SLOP & RECIRCULATION
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER 5- IP´s INFORMATION OF TWIN UNIT CAN BE FOUND IN PID SA-JER-05011-TRJR-480144. 4 POTABLE WATER NOTES 5 DEMI WATER 5, 6, 8 DELETED. 6 N.A. 1- VALVE TO BE OPENED FOR CDU START UP AND OFF SPEC PRODUCT. 2- VALVE TO BE OPENED FOR OFF-SPEC PRODUCT. 7 N.A. 3- VALVE TO BE LOCATED AT MINIMUM DISTANCE FROM B.L. 8 N.A. 4- AT GRADE. AT SAFE LOCATION. 9 HP STEAM 7- GATE VALVE SHALL BE INSTALLED WITH STEM IN OR BELOW THE HORIZONTAL POSITION. 10 MP STEAM 9- PROVIDE MECHANICAL STOP AT 43% OF NORMAL FLOW RATE WITH PRESSURE DROP OF 1.7 BAR. 11 LP STEAM 10- H.V. @ 150ºC SHELL SIDE. 12 HP CONDENSATE 11- FOR VDU BYPASS. 13 MP CONDENSATE 12- START-UP RECIRCULATION LINE. 14 LP CONDENSATE 13- DELETED. 15 BFW 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A.
IP-1333-L
MIN.
MIN.
6"-DIE-011037006-103CS1P-N
TI
2"
CL600
10
103CS1P
INST. PIPING
2"-PRO-011033009-103CH2S-N
MIN.
3/4" D
CL600
11
UC
2"-PRO-011098001-103CS1P-S
MIN.
16"x14"
3
2"-SLP-011098017-103CS1P-P
103CS1P 101CS1P
4
101CS1P AG 301FE0W UG
14" 14" 3/4" D
6"-DIE-011098009-103CS1P-N
2"-SLP-011098016-103CS1P-P
14"-CWS-011098001-101CS1P-N
5
S2
8"-JET-011098001-103CS1P-N
6
2"-SLP-011098016-103CS1P-S
MIN.
D 14"-CWS-011098002-103CS1P-N 103CS1P 101CS1P
7
14"-CWS-011098004-103CS1P-N
0384
S3
T1
14"
8"-HFO-011098012-103CS1P-S
S2
14" 3/4"
8
T3
12
TW
2"
011-E-0037-D
S3
T1
9
2"
CL300
NO POCKET
011-E-0037-B
T3
10
0382
2"
14" CL600
CL300
TW 0383
16"-SLP-011099001-103CS1P-S
2"
0381
11
14"
TW
MIN.
TW
CL300
14" CL600
4"-HFO-011039110-103CS1P-S
CL300
14"
12
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 B.L. PROCESS No 5
011-074 011-076 Item Tags :
011-075 011-080 011-077
ORIGINAL SIGNED IN PROJECT FILE
011-E-0037A/B/C/D
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480136.pid
Discipline: PRO
SA-JER-DS011-TRJR-480136 2271-011-PID-0021-098
REV:
05
Sheet: 5 of 6
SCALE: NONE Format:
A1
41
41
UNIT 011
UNIT 691
40
40
PI
39
103CS2D
103CS2DX
39
0177 38
LEAN AMINE TO 011-C-0007
36
3"-AML-011099001-103CS2D-H
PIPING
3/4"
NOTE 2
38
LPT 37
IP-1307-L MIN.
37
INTERCONNECTING
INST.
DS011-TRJR-480094 3443
35
3/4"-AMI-011099002-103CS2D-P 3/4" D
34
LEAN AMINE FROM AMINE REGENERATION UNIT 203 SA-JER-IP691-TPIT-481002
MIN.
36 35
3/4" D
MIN.
34
MIN.
32 31
LPT
30
28
FROM 011-G-0023 DS011-TRJR-480095 3469
3/4" 3/4"
3"-AMI-011036004-103CH2S-P NOTE 3
NOTE 2
2"x3/4"
103CS2D 101CH2S
103CH2S 103CH2SX 32 31
V 3/4"
30
AMD 7799
IP-1306-L
MIN.
RICH AMINE
29
INST. PIPING
33
MIN.
PI 0178
250 mm MIIN.
33
2"-AMD-011099301-101CH2S-P
3/4"
29
RICH AMINE TO AMINE REGENERATION UNIT 203 SA-JER-IP691-TPIT-481002
MIN.
3/4"-AMI-011099003-103CH2S-P D 3/4" 3/4" D
28
MIN.
27
27
MIN. 3/4"
24
TI 0471
23 22
PI 0180
TT
21
0471
10"-HFO-011010103-103CS1P-S
AMD
21
7801
2"
20
V
PIPING
3/4"
DS011-TRJR-480104 3486
HS 0053
DS011-TRJR-480104
FY 0053 D
IN1
FI 0183
2"
13
2"-CLD-011099301-101CH2S-P
FT
103CS1P 101CH2S
PI
0183
12
0182 INST.
11
1/2"
INST.
PIPING
1/2"
HOT HVGO
NOTE 2
3/4"
PIPING
14 13 12 11
4938
10
IP-1304-L
DS011-TRJR-480100 3478
MIN.
15
V
MIN.
12"-HFO-011038004-103CS1P-S
LPT
2"
25
16
SIGNAL 021-LY-0031-B FROM COKER UNIT21 021-PID-0021-031
UC
14
9
17
2"-HFO-011099101-103CS1P-S
MIN.
3778
15
FROM 011-E-0010
18
MIN.
IN2
SIGNAL TO FY-0053B
VACUUM RESIDUE TO COKER UNIT 021 SA-JER-IP691-TPIT-481002
MIN.
17
10
19
IP-1303-L
2"
16
23
MIN.
FROM 011-E-0014
LPT
NOTE 2
24
250mm MIN.
VACUUM RESIDUE
2" CL600
25
22
MIN.
18
103CH2S 101CH2S
INST.
20 19
2"x3/4"
250 mm MIN.
25
26
MIN.
2"-AMD-011099302-101CH2S-P
26
3/4"
HOT HVGO TO DHC/MHC UNIT 041/051 SA-JER-IP691-TPIT-481002
MIN.
3/4"
8
8
MIN.
2"x3/4" MIN.
7
9
2"
7
UC 6
MIN.
6
2"-HFO-011099001-103CS1P-S 5
5
250mm MIN.
103CS1P 101CH2S
4
2"-CLD-011099303-101CH2S-P 3 2
4 3
SIGNAL 011-HS-0053 TO U-012 012-FY-0053 B
2
25
6"-HFO-011098005-103CS1P-N
4939
1
1
HAGO FROM 011-E-0035 DS011-TRJR-480132 3551
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 5- IP´S INFORMATION OF TWIN UNIT CAN BE FOUND IN SA-JER-DS011-TRJR-480144
NOTES 1,4 DELETED. 2- VALVE TO BE LOCATED AT MINIMUM DISTANCE FROM BL. 3- RICH AMINE SYSTEM IS DESIGNED AT 13.0 barg AND PIPING CLASS SELECTED IS 300# ACCORDING TO INTERCONNECTING HEADER RATING.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
NPS / FBL
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
DESCRIPTION
19 N.A. 20 FUEL OIL 21 FUEL GAS 22 N.A. 23 N.A. 24 N.A. 25 CLOSED DRAIN 26 N.A. 27 L.P. NITROGEN 28 H.P. FLARE 29 L.P. FLARE 30 SOUR/ACID FLARE 31 PILOT GAS 32 AUX COOLING WATER AMD AMINE CLOSED DRAIN
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080 011-079
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 B.L. PROCESS No 7 ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480137.pid
Discipline: PRO
SA-JER-DS011-TRJR-480137 2271-011-PID-0021-099
REV:
05
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
B.L.
37
UNIT 011
PI 0181
INTERCONNECTING
UNIT 691
37
36
36
35
DS011-TRJR-480104 3487
2" NOTE 1
4"-FLO-011099304-101CS1P-N
32
MIN.
31
2"
2"-HFO-011099102-103CS1P-S NOTE 4
4"-HFO-011099104-103CS1P-P
33
D
UC
MIN.
FLO
VACUUM RESIDUE TO STORAGE UNIT 661 SA-JER-IP691-TPIT-481029
MIN.
D
101CS1P 103CS1P
30
34
MIN.
3/4"
31
30
7796
MIN. 28
MIN.
27
2"-HFO-011099103-103CS1P-S
3/4"
29
3/4" TI 0472
D
25
PI 0183
FLO 5440
FROM 011-E-0030 DS011-TRJR-480100 3483
3/4"
V
25 24
IP-1318-L
3/4"
22
NOTE 3
4941
LPT
2" NOTE 2 CL600
8"-HFO-011038005-103CS1P-S
27
25
INST. PIPING
0472
28
26
TT 3/4"
COLD HVGO
103CS1P 101CH2S
2"-CLD-011099302-101CH2S-P
2"-FLO-011099302-101CS1P-N
103CS1P 101CS1P
26
D
250mm MIN.
29
HVGO TO STORAGE UNIT 661 SA-JER-IP691-TPIT-481028
MIN.
23 22
MIN.
NOTE 1 MIN.
21
21
3/4" MIN.
3/4"-HFO-011099002-103CS1P-S 2"-FLO-011099303-101CS1P-N
19
20 19
2"-HFO-011099003-103CS1P-S
FLO
D
17
103CS1P 101CH2S
5435
103CS1P 101CS1P
18
3/4"
D
2"x3/4"
UC
2"-CLD-011099304-101CH2S-P
18
250mm MIN.
20
MIN.
23
35
V IP-1319-L
32
24
2"
MIN.
33
FROM 011-E-0031
NOTE 2
16"-HFO-011040106-103CS1P-S
3/4"
MIN.
VACUUM RESIDUE
34
LPT
INST. PIPING
17
16
16 25
15
15
4943
14
LVGO FROM 011-E-0029
13
DS011-TRJR-480098 3472
14
6"-DIE-011037006-103CS1P-N
13
12
12
8 7
11
READABLE
6"
16"x6"
FI 0112
6"-FLO-011099305-103CS1P-N
3/4"
101CS1P
MIN.
103CS1P
9
8"-HFO-011099003-103CS1P-S
10
16"-HFO-011099103-103CS1P-S
NOTE 1 11
10
6"-FLO-011099301-101CS1P-N
9 FLO
8
2191
CL300
D
7
6" 6
6
NC
5
4
4
3
3
1
10"-HFO-011099104-103CS1P-H
16"-SLP-011099001-103CS1P-S
2
ATM. RESIDUE
LVGO
TO BL.
TO FUEL OIL BLENDING
TO SLOP
DS011-TRJR-480136 3604
DS011-TRJR-480132 7815
DS011-TRJR-480136 3605
SLOP & RECIRCULATION
SLOP & RECIRCULATION
TO BL. DS011-TRJR-480136 8303
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 5- IP´S INFORMATION OF TWIN UNIT CAN BE FOUND IN PID SA-JER-DS011-TRJR-480144.
NOTES 3, DELETED. 1- VALVE TO BE OPENED FOR START-UP AND OFFSPEC PRODUCT. 2- VALVE TO BE LOCATED AT MINIMUM DISTANCE FROM BL. 4- VDU BYPASS. 5- DELETED.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
6"-DIE-011037006-103CS1P-N
5
2 1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
01
24-MAY-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
NPS / STG
RDP / MAC
JAL
REV
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
FLUSHING OIL
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 B.L. PROCESS No 8
Item Tags :
011-075 011-080 011-077
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480138 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480138 2271-011-PID-0021-099
REV: 05
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
41
011-D-0019 DILUTION STEAM POT
40
40
TRIM: MPS-011028601-103CS1P INSULATION: H
39
39
ZC 1/2"D3/4" 12.00
0334
+
38
RESET
NOTE 13 ZHXS ES
37 36
0013
35
ZHXS 0013 L
34
ZPZV 0013
ZHSR
0337
0013 3/4"
31
ZLC 0013
ZLO 0013
ZYC 0013
ZHA 0013
ZLS 0013 C
ZLS 0013 O
ZY 0013
ZHS 0013
35
ZPI
34
0013 A XYV 0013
S
+
OPEN
36
V
ES
33
CLOSED
37
+
ZC
NOTE 1
BY-PASS
INST.
NOTE 12
33
PIPING 1"-IAI-011220305-301CG2P-N
1"-IAI-011028301-301CG2P-N DE
32
38
17
MFR. PIPING
PIPING. MFR.
32
6278
31
ATM
30 29
30
D 3/4" ZV 0013
29
+
LO
28 27
ZC
ZHSR
0337
0012
RESET
FC TSO NOTE 3
10"-MPS-011028301-103CS1P-H
28
10 2184
LPT
27
26
26
ZYV 0012
CLOSED
+
25
S
IA
24
ZLC 0012
ST
OPEN POSITIONER BY-PASS ZLO 0012
ZYC 0012
ZHA 0012
25
8"
23 22
ZV 0012
ATM
+
21
ZLS 0012 C
ZLS 0012 O
ZY 0012
3/4"
ZHS 0012
3/4"
D
3/4"
3/4"
23
D
22
2" V
LPT
FC TSO
D
D
21
NC
NOTE 10 20
24
13
DE
20
NO POCKETS
011-D-0019
19
8"
19
B1
18
18
ST 6"
3/4"
NOTE 9
V
17
17
2" L1A
13
16
3/4" D
15
3/4" D
3/4" D
D
14
NC
13
15
1000 mm
3/4"
16
MAG
14
LG
8"-MPS-011028302-103CS1P-H
A1
0115
8"
12
H1
10
13
2183
12
8"
11
11
2"
10
10
L1B
D
1250 mm
8
INST.
7 6 5
3 2 1
8"-MPS-011028002-103CS1P-H
10"-MPS-011028301-103CS1P-H
4
EMERGENCY STEAM
DILUTION STEAM
TO PASS 1 TO 8
TO PASS 1 TO 8
DS011-TRJR-480070 4528
DS011-TRJR-480070 4526
9 8
B2
2"
7
2"-MPC-011028305-103CS1P-H
3/4"
9
6
2"x1"
3/4" D
2"-MPC-011028301-103CS1P-H
3 13
3/4" D
2
3/4" D 1
NC
NOTES 2,4,5,6,7,8 DELETED. 1- LOCAL EMERGENCY SWITCH BEHIND FIREWALL OR IN SAFE LOCATION 3- 011-ZV-0013 TO BE LOCATED AT MINIMUM DISTANCE FROM INJECTION POINT. 9- POT BY PIPING. 10- DILUTION STEAM. 11-DESIGN PRESSURE: 19 barg + FV 12- ALR VESSEL TO ALLOW 3 FULL STROKES CAPACITIES AND SHALL BE LOCATED OUTSIDE THE FIRE HAZARDOUS AREA. 13- 1002D VOTING LOGIC BETWEEN SIGNALS ZHXS-0013-A (PIB) AND ZHXS-0013-B (MCB). mm mm barg °C ºC barg °C
2"x1"
2"x3/4" 3/4" 2"x3/4"
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
011-D-0019 VERTICAL 1900.0 700.0 14.00 250.00 19.00 350.00
1"
4
2186
GENERAL NOTES
DRUM TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
5
Z 0006
NOTE 11
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
NPS / FCB
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM HEATER INLET
011-074 011-076 Item Tags :
011-075 011-080
011-D-0019
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480139 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480139 2271-011-PID-0021-028
REV: 05
Sheet: 5 of 5
SCALE: NONE Format:
A1
41
0170
40 39
37
16"-DIE-011010001-103CS1P-H
DS011-TRJR-480018 3102
35
3/4" 3/4"
PDV 0385
31
3/4"-DIE-011098011-103CS1P-P
2"x3/4"
2"-CLD-011098322-101CH2S-P
+
30 29
PDT
PDC
0385
0385
16"x10" FO 10" 16"x10"
ES
ZHXS
ZC
ZHSR
0041
0402
0041
NC
8"
ZYV 0041
5428
+
IA DE
OPEN
POSITIONER
BY-PASS
29
ZLC
ZLO
ZYC
ZHA
0041
0041
0041
0041
28
INST. PIPING
ZLS 0041 C
0426 TT 0465
ZLS 0041 O
ZY 0041
ZV 0041
3/4"
ZHS 0041
25
INST. PIPING
+
26
PI 0169
ATM
PT
INST. PIPING
2"
24
3/4"
23
LPT 16"-DIE-111014001-103CS1P-H
16"-DIE-011098001-103CS1P-H FC NOTES 1,2,3,7 TSO
DS011-TRJR-480043 3240
MIN. MIN.
21 20
NOTE 4
MIN.
MIN.
TO 011-C-0002
CLOSED
27
26
22
31
TT 0465
3/4"
LAGO PA
25 4973
S
PI
16"x8"
27
23
32
RESET
30
25
28
24
33
16"x8"
0426
25
103CS1P 101CH2S 2"-CLD-011098309-101CH2S-P
NOTE 9
MIN.
35 34
ES
0041 L
103CS1P 101CH2S
3/4" 32
37
250mm MIN.
INST. PIPING
38
36
2"-DIE-011098012-103CS1P-P
33
NOTE 4
2" UC NC
ZHXS
16"-DIE-111018003-103CS1P-H LAGO PA TO NAPHTHA SPLITTER REBOILER IN NHDT UNIT 111 SA-JER-DS111-TRJR-480042
MIN.
MIN.
16"-DIE-011098008-103CS1P-H
39
MIN.
36
40
INST. PIPING
MIN.
2"
34
UNIT 111
3/4"
2"
V
MIN.
LAGO PA FROM 011-E-0013
LPT NOTE 3
MIN.
38
41
UNIT 011 UNIT 111
PI
22
LAGO PA FROM NAPHTHA SPLITTER REBOILER IN NHDT UNIT111 SA-JER-DS111-TRJR-480042
2"
21 20
2"-DIE-011098007-103CS1P-P MIN.
18
19
2" UC
18
MIN.
19
17
17
103CS1P 101CH2S
15
16
250mm MIN.
16
2"-CLD-011098308-101CH2S-P
14
15 14
PI
13
13
0172
25
12
12
4974
NOTE 5 11
8"
9
FROM 011-G-0007
11
3/4" V 8"-NAP-111018002-103CH2S-N
8"-NAP-011021002-103CH2S-N
MIN.
NAPHTHA
10
3/4"
INST. PIPING
NOTE 3
DS011-TRJR-480051 3257
NOTE 4
MIN.
10
NAPHTHA TO NHDT UNIT 111 SA-JER-DS111-TRJR-480043
MIN.
9
8
8
3/4"-NAP-011098004-103CH2S-N 7
7
3/4" UC
2"x3/4" 5 NAPHTHA
3
TO 011-E-0037 A/B
8"-NAP-011098003-103CH2S-N
1
NC 2"-CLD-011098312-101CH2S-N
NOTE 8 NAPHTHA TO 011-G-0003
4
103CH2S 101CH2S
DS011-TRJR-480136 3599
2
5
3
250mm MIN.
4
6
MIN.
MIN. 6
2
4"-NAP-011021006-103CH2S-N
1
DS011-TRJR-480022 3146
25 4975
05
13-MAR-2013
AB
AB: AS BUILT
MJR/ STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR/ STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / FBL
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
VJS / STG
RDP / MAC
JAL
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 5- IP´S INFORMATION OF TWIN UNIT CAN BE FOUND IN PID SA-JER-DS011-TRJR-480144.
NOTES 6 DELETED. 1- BATTERY LIMIT ZV. 2- VALVE TO BE LOCATED AT LEAST 7.5 m BEYOND THE EDGE OF ANY FIRE HAZARDOUS ZONE. 3- VALVE TO BE LOCATED AT MINIMUM DISTANCE FROM BL. 4- DEDICATED INTERCONNECTING PIPERACK BETWEEN UNITS 011 AND 111. 5- VALVE TO BE OPENED ONLY DURING FILLING PHASE FOR STARTUP. 7- EACH BL EMERGENCY SHUTDOWN VALVE SHALL HAVE A DEDICATED SAFE LOCATION PUSHBUTTON. THE SAFE-LOCATION ACTUATING BUTON SHALL BE GROUPED TOGETHER AND INSTALLED AT GRADE AND LOCATED MORE THAN 15 M FROM ANY FIRE-HAZARDOUS EQUIPMENT OR PROCESS VESSEL. SAFE-LOCATION BUTTONS SHALL ALSO BE AT LEAST 7.5 M BEYOND THE EDGE OF ANY FIRE-HAZARDOUS ZONE. 8- NAPHTHA FILLING LINE. 9- 1002D VOTING LOGIC BETWEEN SIGNALS ZHXS-0041-A (PIB) AND ZHXS-0041-B (MCB).
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
DESCRIPTION
19 N.A. 20 FUEL OIL 21 FUEL GAS 22 N.A. 23 N.A. 24 N.A. 25 CLOSED DRAIN 26 N.A. 27 L.P. NITROGEN 28 H.P. FLARE 29 L.P. FLARE 30 SOUR/ACID FLARE 31 PILOT GAS 32 AUX COOLING WATER FLO FLUSHING OIL AMD AMINE CLOSED DRAIN CND TURBINE CONDENSATE 99
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 B.L. PROCESS No 6 ORIGINAL SIGNED IN PROJECT FILE
Item Tags :
011-075 011-080 011-077 011-079 011-071 011-220
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480140 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480140 2271-011-PID-0021-098
REV: 05
Sheet: 6 of 6
SCALE: NONE Format:
A1
41
41
011-S-0001 HVGO PUMP AROUND FILTER
40
40
TRIM: HFO-011013601-103SD0P
H
PDI
39
39
0024
38
38
37
37
PDT 0024
36
36
35
35
NOTE 6 1"D2" 29.02
34
34
+
PZV 0075
32
33
3/4" V 3"x2"
+
CL600
LO FB
CL300
31
2"x1"
30
NOTE 3
3"-LFL-011013301-101CH2F-N
V
2"-HFO-011013003-103CL2P-S
3/4"
FC 0012
PI INST. PIPING
3/4"
+
1/2" 1/2"
2"
14"-HFO-011013003-103CL2P-S
NOTE 7
FV 0012 12" 14"x12"
14"x12" MIN.
20
10 ø MIN.
4"
3/4"
INST. PIPING
UC 103CL2P 103SD0P
3/4"
FO
2"
2"-HFO-011013324-103SD0P-P MIN.
NOTE 2
3/4" D
3/4"
D
3/4"
D
3/4" 3/4"
CL600
CL600 A B
14"-HFO-011013005-103SD0P-S
011-S-0001 CL600 NOTE 1
4"x2"
2"
13 12
3/4" D
2"x3/4"
2"-CLD-011013308-101CH2S-P
2"-FLO-011013305-101CS1P-N
2"-CLD-011013309-101CH2S-P
3/4"
3/4"
3/4"
3/4"
21
3/4"
D
3/4"
D
18 17 16 15 14
OLW
13 12
NOTE 1
11
14"-HFO-011013004-103SD0P-S
9 8
MIN.
TV 0069 +
10" MIN.
6
MIN.
6379
NOTE 5
3/4"-OLW-011013301-101CS1P-N
NOTE 2
2"-HFO-011013010-103SD0P-S MIN.
3/4"
2" D
3
MIN.
4
19
FLO
10
MIN.
FC
4"-FLO-011013308-101CS1P-N
2"-HFO-011013003-103CL2P-S
8
5
20
25
4976
7
22
2859
25
9
D
3/4"
NOTE 2
MIN.
250mm MIN.
2231
11 10
103SD0P 101CH2S
FLO
103CL2P 101CH2S
3/4"
3/4"
INST. PIPING
4"-HFO-011013006-101SD0P-S
250mm MIN.
MIN.
103CL2P 103SD0P
14
3/4"-HFO-011013013-103CL2P-S
D
2"-HFO-011013009-103SD0P-S
101CS1P 103CL2P
15
NC
3/4"
103SD0P 101CS1P
14"-HFO-011013003-103CL2P-S
16
6" 14"x6"
MIN.
10"-HFO-011039005-103CL2P-S
14"x6"
24
MIN.
18 17
PT 0040
TW 0476
4"x2"
19
PI 0025
23
CL600
S CL600 D
3/4"
14"-HFO-011013003-103CL2P-S
2"
W
25
14"-HFO-011013006-101SD0P-S
2" 21
1/2"
MIN.
0023
V
INST. PIPING
26
101SD0P
1/2"
MIN.
24" M
103SD0P
FT 0012
MIN.
22
TT 0069
D
PI 0040
PI 0454
V
CL600
23
TC 0069
2"
103CL2P 103SD0P
TT 0070
24
27
2"-HFO-011013015-103SD0P-S
2230
25
28
101SD0P 101CS1P
26
29
103SD0P 101SD0P
FLO
2"-FLO-011013304-101CS1P-N
30
MIN.
101CS1P 103CL2P
H
31
2"
LO V FB 2"
TI 0070
32
2014
NOTE 2
3/4"
27
29
NOTE 3
3/4"
29 28
0.2 %
103SD0P 101CH2F
33
7 6 5 4 3
10" HVGO PA
3/4"
250mm MIN.
103CL2P 101CH2S
D
MIN.
3/4"-HFO-011013014-103CL2P-S 2"x3/4"
2"-CLD-011013307-101CH2S-P
103SD0P 101CH2S
10"-HFO-011039005-103CL2P-S
MIN.
14"-HFO-011013003-103CL2P-S
1
NC
HVGO
25
FROM 011-G-0017
DS011-TRJR-480025 4047
4977
DS011-TRJR-480101 3485
25 2858
NOTES 1- FILTER TO BE LOCATED AT MINIMUM DISTANCE FROM COLUMN 011-C-0003. 2- CONNECTION ON TOP OF LINE. 3- GATE VALVE SHALL BE INSTALLED WITH STEM IN OR BELOW THE HORIZONTAL POSITION. 4- DES PRESS. (barg) : 30.0 AND FV
m³/h barg °C barg °C
5- FOR THE FILLING PURPOSE. 6- SET PRESSURE OF PZV-0075 HAVE BEEN READJUSTED BASED ON A DISTANCE FROM UPPER TL OF 011-S-0001 TO PZV. THIS DIFFERENT OF EVALUATION SHOULD NOT BE HIGHER THAN 12,3 METER. 7- EMERGENCY CONNECTION (PYROPHORIC SERVICE) TO BE AT GRADE. 8- DELETED. NOTE 4
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
IRG / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
011-S-0001 BASKET 1175.0 5.10 267.40 30.00 325.00
1
2"-CLD-011013310-101CH2S-P
GENERAL NOTES
FILTERS TYPE DES. CAPACITY OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP.
DS011-TRJR-480080 3311
HVGO PA
FROM 011-E-0016-A/B
2
TO 011-C-0003
250mm MIN.
2
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 HVGO PA FILTER ORIGINAL SIGNED IN PROJECT FILE
Item Tags :
011-075 011-080 011-077
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480141.pid
Discipline: PRO
SA-JER-DS011-TRJR-480141 2271-011-PID-0021-013
REV:
05
Sheet: 3 of 3
SCALE: NONE Format:
A1
41
41
40
ZHSX 0084 L
39
ZHXS
ES
011-Y-0001 011-C-0001 MP STRIPPING STEAM SILENCER
40 39
NOTE 8
ES
0084
38 37
ZC
ZC
ZC
ZHSR
0394
0370
0322
0084
35 34
BY-PASS
POSITIONER
OPEN
CLOSED
ZHA 0084
ZYC 0084
ZLO 0084
ZLC 0084
ZYV 0084 +
S
IA DE
33 32 31
ZHS
ZY
ZLS
ZLS
0084
0084
0084 O
0084 C
ATM
30
4"-MPS-011011306-101CS1P-H
36
38
101CS1P 103CS1P
ZV 0084
37 36
011-Y-0001
ZC
ZC
0394
0322
ZC 0370
TI
27
35
0356
1"-OLW-011011304-101CS1P-N
FMC
H
TI 0194
0007
L
LL
33
FC
32
FT
31
0007 TT 0356
NC OLW
TT 0194 2"
TI 0357 2"
30
FV 0007
INST.
+
1/2"
2" 8"
28
TSO FC
ZC 0394
34
4"-MPS-011011304-103CS1P-H NOTE 1
ZC 0322
NOTE 9, 10
+
29
RESET
8"x3"
LPT
MIN.
29
PIPING
3" 6"x3" FC TSO
3/4" D
1/2"
6"-MPS-011011302-103CS1P-H LPT
28
10 2173
27
3/4" D
26
26
8"x2"
2"
6"x2"
25
25
NC 24
24
23
23
22
22
8"
4"
21
21
20
20
ST
19
19
18
18
17
3/4" D
3/4"
D
3/4"
17
D
16
16
3/4"
15
D
15
NC
14
14
13
13
13
12
12
11
11
10
10
ST 9
9
8
8
3/4" D
7
3/4"
D
3/4"
D
7
6
6
3/4"
D
5
5
NC 4
4
3
3
8"-MPS-011011302-103CS1P-H
13
2 1
2 1
MP STEAM TO 011-C-0001 DS011-TRJR-480020 3115
Kg/hr barg °C barg °C
011-Y-0001 DIFFUSER + ABSORPTION 1000.0 ATM NOTE 15 350.00 3.50 386.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
05
06-OCT-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS/MAC
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS/MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS/MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR/STG
AVS/MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG/STG
RDP/MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MMG/STG
RDP/MAC
JAL
PREPARED BY
CHECKED BY
REV
GENERAL NOTES
SILENCER TYPE FLOW OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP.
06
POS. 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 1 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 2 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 4 NOTES 5 2,3,4,5,6,7,11,12,13,14 DELETED 6 1- MINIMUM DISTANCE FROM NOZZLE ON COLUMN 011-C-0001. 7 8- LOCAL EMERGENCY SWITCH BEHIND FIREWALL OR AT SAFE LOCATION. 8 9- SILENCER INCLUDES ANTIBIRD MESH. 10- TO ATM. AT SAFE LOCATION. 9 15- MAXIMUM OP. PRESSURE: 3 barg. 10 11 12 13 14 15 16 17 18
COMPANY STATUS
DATE
UTILITIES IDENTIFICATION DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PREFLASH STRIPPING STEAM
011-074 011-076 Item Tags :
011-075 011-080
ORIGINAL SIGNED IN PROJECT FILE
011-Y-0001
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480142 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480142 2271-011-PID-0021-011
REV: 06
Sheet: 3 of 3
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
U011
U012
37
36 35 34
36
IP 1324 L SA-JER-DS011-TRJR-480202
6"-HPW-011071301-106CS1P-H
IP 1724 L SA-JER-DS012-TRJR-480202
6"-HPW-012071301-106CS1P-H
IP 1325 L SA-JER-DS011-TRJR-480202
2"-DWA-011071302-101SR0P-N
IP 1725 L SA-JER-DS012-TRJR-480202
2"-DWA-012071302-101SR0P-N
IP 1328 L SA-JER-DS011-TRJR-480202
12"-MPS-011071301-103CS1P-H
IP 1728 L SA-JER-DS012-TRJR-480202
12"-MPS-012071301-103CS1P-H
35 34
33
33
IP 1329 L SA-JER-DS011-TRJR-480202
20"-LPS-011071301-101CS1P-H
IP 1729 L SA-JER-DS012-TRJR-480202
20"-LPS-012071301-101CS1P-H
32
32
IP 1330 L SA-JER-DS011-TRJR-480202
3"-CND-011071302-103CS1P-H
IP 1730 L SA-JER-DS012-TRJR-480202
3"-CND-012071302-103CS1P-H
31
31
IP 6041 S SA-JER-DS011-TRJR-480207
40"-CWR-011072301-301FE0W-N
IP 6063 S SA-JER-DS012-TRJR-480207
40"-CWR-012072301-301FE0W-N
30
30
IP 6042 S SA-JER-DS011-TRJR-480207
40"-CWS-011072301-301FE0W-N
IP 6064 S SA-JER-DS012-TRJR-480207
40"-CWS-012072301-301FE0W-N
29
29
IP 5012 S SA-JER-DS011-TRJR-480209
2"-PWA-011073301-301PU0W-N
IP 5018 S SA-JER-DS012-TRJR-480209
2"-PWA-012073301-301PU0W-N
IP 6126 S SA-JER-DS011-TRJR-480209
2"-SWA-011073302-301FEOW-N
IP 6132 S SA-JER-DS012-TRJR-480209
2"-SWA-012073302-301FEOW-N
IP 1321 L SA-JER-DS011-TRJR-480211
3"-LPN-011074301-101CS1P-N
IP 1721 L SA-JER-DS012-TRJR-480211
3"-LPN-012074301-101CS1P-N
IP 1322 L SA-JER-DS011-TRJR-480211
3"-INA-011074301-301CG2P-N
IP 1722 L SA-JER-DS012-TRJR-480211
3"-INA-012074301-301CG2P-N
IP 1323 L SA-JER-DS011-TRJR-480211
3"-UTA-011074301-301CG2P-N
IP 1723 L SA-JER-DS012-TRJR-480211
3"-UTA-012074301-301CG2P-N
IP 1326 L SA-JER-DS011-TRJR-480214
12"-FUG-011075301-101CS2P-H
IP 1726 L SA-JER-DS012-TRJR-480214
12"-FUG-012075301-101CS2P-H
23
IP 1327 L SA-JER-DS011-TRJR-480214
2"-PIG-011075302-101CS1P-S
IP 1727 L SA-JER-DS012-TRJR-480214
2"-PIG-012075302-101CS1P-S
23
22
IP 1331 L SA-JER-DS011-TRJR-480219
44"-LPF-011076001-101CH2F-N
IP 1731 L SA-JER-DS012-TRJR-480219
44"-LPF-012076001-101CH2F-N
22
21
IP 1320 L SA-JER-DS011-TRJR-480225
6"-FLO-011077301-101CS1P-N
IP 1720 L SA-JER-DS012-TRJR-480225
6"-FLO-012077301-101CS1P-N
21
20
IP 6039 S SA-JER-DS011-TRJR-480237
8"-AWR-011080302-301FE0W-N
IP 6061 S SA-JER-DS012-TRJR-480237
8"-AWR-012080302-301FE0W-N
20
19
IP 6040 S SA-JER-DS011-TRJR-480237
8"-AWS-011080302-301FE0W-N
IP 6062 S SA-JER-DS012-TRJR-480237
8"-AWS-012080302-301FE0W-N
19
18
IP 1301 L SA-JER-DS011-TRJR-480135
8"-KER-011025001-103CS1P-H
IP 1703 L SA-JER-DS012-TRJR-480135
8"-KER-012025001-103CS1P-H
18
17
IP 1305 L SA-JER-DS011-TRJR-480135
3"-NPH-011098001-103CH2S-P
IP 1705 L SA-JER-DS012-TRJR-480135
3"-NPH-012098001-103CH2S-P
17
16
IP 1308 L SA-JER-DS011-TRJR-480132
8"-SRW-011044002-106CH2S-P
IP 1708 L SA-JER-DS012-TRJR-480132
8"-SRW-012044002-106CH2S-N
16
15
IP 1309 L SA-JER-DS011-TRJR-480132
6"-WST-011098001-101CS2P-N
IP 1310 L SA-JER-DS011-TRJR-480132
8"-HGO-011025003-103CS1P-N
IP 1710 L SA-JER-DS012-TRJR-480132
8"-HGO-012025003-103CS1P-N
IP 1311 L SA-JER-DS011-TRJR-480132
6"-BRN-011042003-101CS4P-N
IP 1701 L SA-JER-DS012-TRJR-480132
6"-BRN-012042003-101CS4P-N
IP 1316 L SA-JER-DS011-TRJR-480132
8"-HGO-011098006-103CS1P-N
IP 1716 L SA-JER-DS012-TRJR-480132
8"-HGO-012098006-103CS1P-N
IP 1332 L SA-JER-DS011-TRJR-480135
6"-WST-011098002-101CS2P-N
IP 1709 L SA-JER-DS012-TRJR-480135
6"-WST-012098002-101CS2P-N
IP 1302 L SA-JER-DS011-TRJR-480133
6"-LGO-011025003-103CS1P-N
IP 1702 L SA-JER-DS012-TRJR-480133
6"-LGO-012025003-103CS1P-N
IP 1313 L SA-JER-DS011-TRJR-480136
16"-SLP-011098001-103CS1P-S
IP 1713 L SA-JER-DS012-TRJR-480136
16"-SLP-012098001-103CS1P-S
28 27 26 25 24
14 13 12 11 10
28 27 26 25 24
NO TWIN
15 14 13 12 11 10
9
9
IP 1314 L SA-JER-DS011-TRJR-480133
18"-CRD-011098001-103CS1P-N
IP 1712 L SA-JER-DS012-TRJR-480133
18"-CRD-012098001-101CS1P-N
8
8
IP 1315 L SA-JER-DS011-TRJR-480133
6"-LGO-011025002-103CS1P-N
IP 1715 L SA-JER-DS012-TRJR-480133
6"-LGO-012025002-103CS1P-N
7
7
IP 1317 L SA-JER-DS011-TRJR-480133
8"-KER-011025002-103CS1P-N
IP 1717 L SA-JER-DS012-TRJR-480133
8"-KER-012025002-103CS1P-N
6 5 4 3 2 1
6
IP 1333 L SA-JER-DS011-TRJR-480136
8"-SLP-011098003-103CS1P-S
IP 1732 L SA-JER-DS012-TRJR-480136
8"-SLP-012098003-103CS1P-S
IP 1312 L SA-JER-DS011-TRJR-480134
6"-SLP-011098002-103CS1P-N
IP 1714 L SA-JER-DS012-TRJR-480134
6"-SLP-012098002-103CS1P-N
IP 1303 L SA-JER-DS011-TRJR-480137
10"-RES-011010003-103CS1P-S
IP 1704 L SA-JER-DS012-TRJR-480137
10"-RES-012010003-103CS1P-S
IP 1304 L SA-JER-DS011-TRJR-480137
12"-HGO-011038004-103CS1P-S
IP 1711 L SA-JER-DS012-TRJR-480137
12"-HGO-012038004-103CS1P-S
IP 1306 L SA-JER-DS011-TRJR-480137
3"-AMN-011036004-103CH2S-P
IP 1706 L SA-JER-DS012-TRJR-480137
3"-AMN-012036004-103CH2S-P
IP 1307 L SA-JER-DS011-TRJR-480137
3"-AMN-011099001-103CS2D-H
IP 1707 L SA-JER-DS012-TRJR-480137
3"-AMN-012099001-103CS2D-H
IP 1318 L SA-JER-DS011-TRJR-480138
8"-HGO-011038005-103CS1P-S
IP 1718 L SA-JER-DS012-TRJR-480138
8"-HGO-012038005-103CS1P-S
IP 1319 L SA-JER-DS011-TRJR-480138
16"-RES-011040006-103CS1P-S
IP 1719 L SA-JER-DS012-TRJR-480138
16"-RES-012040006-103CS1P-S
IP 1334 L SA-JER-DS011-TRJR-480202
2"-LPS-011071303-101CS1P-H
IP 1733 L SA-JER-DS012-TRJR-480202
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
5 4 3 2 1
2"-LPS-012071303-101CS1P-H
05
13-MAR-2013
CLD
CLD: ISSUED CANCELLEED
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MRM / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MRM / STG
RDP / MAC
JAL
00
11-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MRM / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 TWIN UNIT-IPS B.L. DETAILS
Item Tags :
011-075 011-080 011-077 011-079 011-071
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480144.pid
Discipline: PRO
SA-JER-DS011-TRJR-480144 2271-011-PID-0021-100
REV:
05
Sheet: 1 of 1
SCALE: NONE Format:
A1
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 4.
PLANIMETRIC P&ID FOR UTILITIES Document Number SA-JER-DS011-TRJR-480201 SA-JER-DS011-TRJR-480202 SA-JER-DS011-TRJR-480203 SA-JER-DS011-TRJR-480204 SA-JER-DS011-TRJR-480205 SA-JER-DS011-TRJR-480206 SA-JER-DS011-TRJR-480207 SA-JER-DS011-TRJR-480209 SA-JER-DS011-TRJR-480211 SA-JER-DS011-TRJR-480212 SA-JER-DS011-TRJR-480213 SA-JER-DS011-TRJR-480214 SA-JER-DS011-TRJR-480215 SA-JER-DS011-TRJR-480216 SA-JER-DS011-TRJR-480218 SA-JER-DS011-TRJR-480219 SA-JER-DS011-TRJR-480220 SA-JER-DS011-TRJR-480221 SA-JER-DS011-TRJR-480222 SA-JER-DS011-TRJR-480223 SA-JER-DS011-TRJR-480224 SA-JER-DS011-TRJR-480225 SA-JER-DS011-TRJR-480226 SA-JER-DS011-TRJR-480227 SA-JER-DS011-TRJR-480228 SA-JER-DS011-TRJR-480229 SA-JER-DS011-TRJR-480230 SA-JER-DS011-TRJR-480231 SA-JER-DS011-TRJR-480232 SA-JER-DS011-TRJR-480233 SA-JER-DS011-TRJR-480234 SA-JER-DS011-TRJR-480235 SA-JER-DS011-TRJR-480237 SA-JER-DS011-TRJR-480238
Description
Rev.
PID FOR CDU LPC SYSTEM, SH 1 OF 7 PID FOR CDU MPS, LPS, LPC, BFW, CND, DWA, MPC UTILITY DISTRIB, SH 2 OF 7 PID FOR CDU MPS, LPS, LPC, BFW, CND, DWA, MPC UTILITY DISTRIB, SH 3 OF 7 PID FOR CDU MPS, LPS, LPC, BFW, CND, DWA, MPC UTILITY DISTRIB, SH 4 OF 7 PID FOR CDU MPS, LPS, LPC, BFW, CND, DWA, MPC UTILITY DISTRIB, SH 5 OF 7 PID FOR CDU MPS, LPS, LPC, BFW, CND, DWA, MPC UTILITY DISTRIB, SH 6 OF 7 PID FOR CDU CWS, CWR UTILITY DISTRIBUTION PID FOR CDU PWA, SWA UTILITY DISTRIBUTION PID FOR CDU LPN, UTA, INA UTILITY DISTRIBUTION, SH 1 OF 3 PID FOR CDU LPN, UTA, INA UTILITY DISTRIBUTION, SH 2 OF 3 PID FOR CDU LPN, UTA, INA UTILITY DISTRIBUTION, SH 3 OF3 PID FOR CDU PIG, FUG KO DRUM PID FOR CDU FUG, PIG UTILITY DISTRIBUTION, SH 2 OF 2 PID FOR CDU CLOSE DRAIN UTILITY DISTRIBUTION PID FOR CDU LPF UTILITY DISTRIBUTION, SH 1 OF 4 PID FOR CDU LPF UTILITY DISTRIBUTION, SH 2 OF 4 PID FOR CDU LPF UTILITY DISTRIBUTION, SH 3 OF 4 PID FOR CDU LPF UTILITY DISTRIBUTION, SH 4 OF 4 PID FOR CDU FLO UTILITY DISTRIBUTION, SH 1 OF 6 PID FOR CDU FLO UTILITY DISTRIBUTION, SH 2 OF 6 PID FOR CDU FLO UTILITY DISTRIBUTION, SH 3 OF 6 PID FOR CDU FLO UTILITY DISTRIBUTION, SH 4 OF 6 PID FOR CDU CLOSED DRAIN UTILITY DISTRIBUTION, SH 1 OF 7 PID FOR CDU CLOSED DRAIN UTILITY DISTRIBUTION, SH 2 OF 7 PID FOR CDU CLOSED DRAIN UTILITY DISTRIBUTION, SH 3 OF 7 PID FOR CDU CLOSED DRAIN UTILITY DISTRIBUTION, SH 4 OF 7 PID FOR CDU CLOSED DRAIN UTILITY DISTRIBUTION, SH 5 OF 7 PID FOR CDU CLOSED DRAIN UTILITY DISTRIBUTION, SH 6 OF 7 PID FOR CDU CLOSED DRAIN DRUM PID FOR CDU AMINE CLOSED DRAIN UTILITY DISTRIBUTION PID FOR CDU MPS, LPS, LPC, BFW, CND, DWA, MPC UTILITY DISTRIBUTION (OPC) PID FOR CDU LPN, UTA, INA UTILITY DISTRIBUTION (OPC) PID FOR CDU AWS, AWR UTILITY DISTRIBUTION, SH 1 OF 4 PID FOR CDU AWS, AWR UTILITY DISTRIBUTION, SH 2 OF 4
05 05 05 05 05 05 05 05 05 05 05 05 05 03 05 05 05 05 05 05 05 05 05 05 05 05 05 05 05 05
05 05
DOCUMENT No.: SA-JER-DS011-TRJR-400100
Document Number SA-JER-DS011-TRJR-480239 SA-JER-DS011-TRJR-480240 SA-JER-DS011-TRJR-480241 SA-JER-DS011-TRJR-480242 SA-JER-DS011-TRJR-480243 SA-JER-DS011-TRJR-480244 SA-JER-DS011-TRJR-480245 SA-JER-DS011-TRJR-480246 SA-JER-DS011-TRJR-480247 SA-JER-DS011-TRJR-480248 SA-JER-DS011-TRJR-480249 SA-JER-DS011-TRJR-480250 SA-JER-DS011-TRJR-480251 SA-JER-DS011-TRJR-480252 SA-JER-DS011-TRJR-480253 SA-JER-DS011-TRJR-480254 SA-JER-DS011-TRJR-480255 SA-JER-DS011-TRJR-480256 SA-JER-DS011-TRJR-480257 SA-JER-DS011-TRJR-480258 SA-JER-DS011-TRJR-480259 SA-JER-DS011-TRJR-480260 SA-JER-DS011-TRJR-480261 SA-JER-DS011-TRJR-480262 SA-JER-DS011-TRJR-480263 SA-JER-DS011-TRJR-480264 SA-JER-DS011-TRJR-480265 SA-JER-DS011-TRJR-480266 SA-JER-DS011-TRJR-480267 SA-JER-DS011-TRJR-480268 SA-JER-DS011-TRJR-480269 SA-JER-DS011-TRJR-480270 SA-JER-DS011-TRJR-480271 SA-JER-DS011-TRJR-480272 SA-JER-DS011-TRJR-480273 SA-JER-DS011-TRJR-480274 SA-JER-DS011-TRJR-480275 SA-JER-DS011-TRJR-480289 SA-JER-DS011-TRJR-480290
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
Description
Rev.
PID FOR CDU AWS, AWR UTILITY DISTRIBUTION, SH 3 OF 4 PID FOR CDU AWS, AWR UTILITY DISTRIBUTION, SH 4 OF 4 PID FOR CDU SANITARY WATER SYSTEM - OPERATOR SHELTER PID FOR CDU FLO UTILITY DISTRIBUTION, SH 5 OF 6 PID FOR CDU FLO UTILITY DISTRIBUTION, SH 6 OF 6 PID FOR CDU PUMP AUXILIARY SEAL PLAN DETAILS No 1 PID FOR CDU PUMP AUXILIARY SEAL PLAN DETAILS No 2 PID FOR CDU PUMP AUXILIARY SEAL PLAN DETAILS No 3 PID FOR CDU PUMP AUXILIARY SEAL PLAN DETAILS No 4 PID FOR CDU PUMP AUXILIARY SEAL PLAN DETAILS No 5 PID FOR CDU PUMP AUXILIARY SEAL PLAN DETAILS No 6 PID FOR CDU PUMP AUXILIARY SEAL PLAN DETAILS No 7 PID FOR CDU PUMP AUXILIARY SEAL PLAN DETAILS No 8 PID FOR CDU PUMP AUXILIARY SEAL PLAN DETAILS No 9 PID FOR CDU PUMP AUXILIARY SEAL PLAN DETAILS No 10 PID FOR CDU PUMP AUXILIARY DETAILS FOR 011-G-0001 A-B No 1 PID FOR CDU PUMP AUXILIARY DETAILS FOR 011-G-0001 A-B No 2 PID FOR CDU PUMP AUXILIARY DETAILS FOR 011-G-0002 A-B No 1 PID FOR CDU PUMP AUXILIARY DETAILS FOR 011-G-0002 A-B No 2 PID FOR CDU PUMP AUXILIARY DETAILS FOR 011-G-0004 A-B No 1 PID FOR CDU PUMP AUXILIARY DETAILS FOR 011-G-0004 A-B No 2 PID FOR CDU PUMP AUXILIARY DETAILS FOR 011-G-0017 A-B No 1 PID FOR CDU PUMP AUXILIARY DETAILS FOR 011-G-0001 A-B No 2 PID FOR CDU VDU OFF GAS COMPRESSOR - LUBE OIL SYSTEM PID FOR CDU PUMP AUXILIARY SEAL PLAN DETAILS No 11 PID FOR CDU VDU 011-K-0001 SHAFT SEAL ARRANGEMENT PID FOR CDU VDU 011-K-0001 CONDITION MONITORING PID FOR CDU VDU 011-K-0001 LOCAL CONTROL PANEL SIGNALS PID FOR CDU 011-K-0003 AUXILIARY DETAILS No 1 PID FOR CDU 011-K-0003 AUXILIARY DETAILS No 2 PID FOR CDU 011-K-0002 AND AIR FILTERS AUXILIARY DETAILS No 1 PID FOR CDU 011-K-0002 AND AIR FILTERS AUXILIARY DETAILS No 2 PID FOR CDU PUMPS AUXILIARY SIGNALS AND ALARMS DETAILS No 1 PID FOR CDU PUMPS AUXILIARY SIGNALS AND ALARMS DETAILS No 2 PID FOR CDU SAMPLE DETAILS No 1 PID FOR CDU SAMPLE DETAILS No 2 PID FOR CDU SAMPLE DETAILS No 3 PID FOR CDU ANALYZER AUXILIARY DETAILS No 1 PID FOR CDU ANALYZER AUXILIARY DETAILS No 2
05 05
05 05 03 03 03 03 03 03 03 03 03 03 03 03 03 03 03 03 03 03 03 03 03 03 03 03 03 03 03 03 03 04 04 04 05 05
DOCUMENT No.: SA-JER-DS011-TRJR-400100
Document Number SA-JER-DS011-TRJR-480291 SA-JER-DS011-TRJR-480306 SA-JER-DS011-TRJR-480307 SA-JER-DS011-TRJR-480308 SA-JER-DS011-TRJR-480309 SA-JER-DS011-TRJR-480310 SA-JER-DS011-TRJR-480311 SA-JER-DS011-TRJR-480312
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
Description
Rev.
SA-JER-DS011-TRJR-480314
PID FOR CDU ANALYZER AUXILIARY DETAILS No 3 PID FOR CDU UTILITY STATIONS No 1 PID FOR CDU UTILITY STATIONS No 2 PID FOR CDU UTILITY STATIONS No 3 PID FOR CDU UTILITY STATIONS No 4 PID FOR CDU UTILITY STATIONS No 5 PID FOR CDU CRUDE HEATER INLET PID FOR CDU VACUUM HEATER INLET PID FOR CDU MPS, LPS, LPC, BFW, CND, DWA, MPC UTILITY DISTRIB, SH 7 OF 7 PID FOR CDU UTILITY STATIONS No 6
00
SA-JER-DS011-TRJR-480315
PID FOR CDU UTILITY STATIONS No 7
00
SA-JER-DS011-TRJR-480313
05 05 05 05 05 05 05 05 05
41
41
40
011-D-0026 LPC DRUM
39
TRIM: LPS-011071601-101CS1P / LPC-011071601-103CS1P INSULATION: H
011-A-0008 FLASH VAPOR CONDENSER
40
N
39
38
38
37
37
36
36
35
35
MP CONDENSATE FROM HEADER DS011-TRJR-480202
34
NOTE 1
33
34
6342
PV 0409
33
+
NOTE 1
2"
FO TSO CL300
32
75%-100%
32 CND
3"-CND-011071302-103CS1P-H
31
DS011-TRJR-480202
2"
7833
30
NOTES 15, 16
29
4"x2" NOTE 1
2"
25
6"x3" 3/4"
NC MIN.
24
CL300
FB LC NOTE 2
V
23
NOTE 12
V 011-SP-0038
2"
22
+
CL300
6"x3" 3/4"
V
3/4"
PZV 0063
8"-LPS-011071004-101CS1P-P 8"x4" NOTE 6
+
21 20 19
PI
H
0455
L
FB LO NOTE 2
NOTE 14
SPLIT RANGE
24 23
0409
ZC 0416
22
2"-OLW-011071305-101CS1P-N
PI PIPING INST.
V
2"
W
011-D-0026 NOTE 13
A2 A3
0409
700 mm MIN
2"
PIPING OLW
NOTES 3,18
A4 L3B L2B
14 13
2"
3/4"
15
1-1/2"x1"
LG 0129
2"
MAG
LT 0130
LT 0131
LI 0131
L1A
2"
FO 1"
3/4" D
1/4"
1/4"
2"-LPS-011071416-101CS1P-P
1-1/2"x1/2"
1-1/2"x1/2"
H
3/4" D
NC 1/2"
L
FC 0195
1/4"
L2A
S1
FT 0195
2" 1/4" L3A
6600 mm
2"-LPC-011071004-101CS1P-H
INST. PIPING INST.
B2 D 2" 4"
3/4"
NC
PIPING 1/2"
LC
13 12 11
3/4"-CND-011071307-103CS1P-H 2"-OLW-011071304-101CS1P-N
SC
10
011-SC-0050 TYPE 7 NOTE 17
9 8
1/2" 7
0130
LV 0130 +
6 5
LPT 4"-LPC-011071002-101CS1P-H
2"-OLW-011071303-101CS1P-N
1
2"-OLW-011071302-101CS1P-N OLW
UC
3/4"
3/4"
011-G-0028-A NOTE 10
NOTE 7
D NOTE 8 PIPING INST. 3/4"
101CS1P 103CS1P UC
PI
3/4"
NOTE 7
INST. PIPING 3/4" D
3/4"
011-G-0028-B
1
PI 0422
3"x1"
4"x3"
4"-CND-011071304-103CS1P-H 3/4" D WATER TO OLW
INST. PIPING
M
DS011-TRJR-480250
1/2"-CND-011071302-103CS1P-P ZC 0101
MCC
TYP. 1
MG 0028 A
1/2"-CND-011071306-103CS1P-P
10796
011-G-0028-A / B LPC PUMPS
ZC 0101
2
NC
3/4"
OLW
M
3
D NOTE 8 PIPING INST. NOTE 10
4"x3"
OLW 4"-CND-011071303-103CS1P-H
3/4"
0324
0421
3"x1"
4
3/4" D
3"x1-1/2" 1-1/2" 3"x1-1/2"
PI
3/4"
0319
PIPING
101CS1P 103CS1P
INST.
PI 2
5
LPT
INST.
2"-LPC-011071005-101CS1P-P
3/4" D
3"-CND-011071306-103CS1P-H
4"-LPC-011071002-101CS1P-H 2"-LPC-011071006-101CS1P-P
PIPING
2"-OLW-011071301-101CS1P-N
1-1/2" 3"x1-1/2" FC
4"-LPC-011071002-101CS1P-H
3
6
3"x1-1/2"
3"-CND-011071302-103CS1P-H
4
MCC
TYP. 1
05
13-MAR-2013
AB
WATER TO OLW
04
30-SEP-2011
DS011-TRJR-480250
03
10797
MG 0028 B
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
RDP / MAC
JAL
00
30-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
ARV / STG
RDP / MAC
JAL
INSULATION: H REV
GENERAL NOTES
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP. PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
16
NOTE 19
101CS1P 103CS1P 1-1/2"x1"
2"
L1B
2"
FI 0176
14
12
10
FT 0176
1/2"
+
1-1/2"-CND-011071309-101CS1P-H
NC
2"
2"
11
FV 0195
17
1/2"
2"-LPC-011071001-101CS1P-P
MIN.
M1
15
2"x1-1/2"
18
INST.
3"-MPC-011071302-103CS1P-H
16
ID 24"
19
INST. PIPING
3/4"
4"x3"
4"
20
MA 0008
0420
PT
P1
6"
6899
7
MCC TYPYCAL 7
21
B1
A1
3/4" D
25
PC
2" V
6"-LPC-011071003-101CS1P-H
8
2"-LPC-011071007-101CS1P-P
M
4"-LPC-011071303-101CS1P-H
DS011-TRJR-480202
UC
26
2"x1-1/2"
4"
6"
9
27
1-1/2" D
0409
3/4"
PT 0455
PY 0480
NOTE 5
PY
INST. PIPING
18 FROM LPC HEADER
0%-75%
1-1/2"-CND-011071308-103CS1P-H
26
PZV 0064
28
101CS1P 103CS1P
8"-LPS-011071005-101CS1P-P 8"x4" NOTE 6
29
2"
+
6"-LPS-011071001-101CS1P-P
27
4"
4"-LPS-011071003-101CS1P-P
3"L4" 3.50
+
4"-LPS-011071002-101CS1P-P
3"L4" 3.50
28
17
30
011-A-0008 NOTE 1
m³/h barg bar barg °C kg/m³
011-G-0028-A / B CENTRIFUGAL 13.3 15.10 11.69 29.00 134.00 932.0
AIRFINS TYPE SURFACE OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP DUTY
011-D-0026 VERTICAL 2900.0 1000.0 2.00 134.00 3.50 150.00
mm mm barg °C barg °C
m² barg °C barg °C Gcal/h
011-A-0008 FORCED 9.0 2.00 134.00 3.50 162.00 0.34
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
31
9,11 DELETED 1- TO ATM AT SAFE LOCATION. 2- BLOCK VALVE SHALL BE INSTALLED WITH THE STEM IN OR BELOW THE HORIZONTAL POSITION. 3- STRAIGHT RUN FLOW 5 TO 10 DIAMETERS UPSTREAM THE GLOBE VALVE. 4- DELETED. 5- AUTOMATIC VARIABLE PITCH CONTROL (FAIL OPEN). 6- PROVIDE WEEP HOLE ø=6 mm AT LOW POINT. 7- PROVIDE A STRAIGTH LENGTH OF PIPE OF AT LEAST 5 TIMES THE LINE DIAMETER. 8- CHECK VALVE SHALL BE INSTALLED HORIZONTALY. 10- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JER-DS011-TRJR-480250. 12- MECHANICAL LINK. 13- FOR NOZZLES DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING. 14- SCOPE OF AERO VENDOR. 15- 1% SLOPE, IN LAST PASS OF TUBE BUNDLE IS TO BE CONSIDERED. 16- AIR COOLER HAS 1 BAY WITH 1 MOTOR /FAN AND 1 BUNDLE. 17- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS011-TRJR-480274. 18- MANUAL GLOBE VALVE OPEN 100 %. 19- MAXIMUM TRAVEL STOP IS REQUIRED AT 110% CV NORMAL CALCULATED (CV=1.177).
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 LPC SYSTEM
011-074 011-076 Item Tags :
011-075 011-080
011-D-0026
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
011-A-0008
011-G-0028-A/B
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480201.pid
Discipline: PRO
SA-JER-DS011-TRJR-480201 2271-011-PID-0021-071
REV:
05
Sheet: 3 of 7
SCALE: NONE Format:
A1
NOTE 1
3/4" V 8"x6"
PC 0417
2"
FB NOTE 5 LC 2"
50-100%
3"
2000 mm
34
32
OLW
31
6"-BFW-011071303-101CS1P-H 2"-BFW-011071306-101CS1P-H
30
011-D-0007 DS011-TRJR-480112
101CS1P FI
29
4699
106CS1P
+
CSC FT 0196
6"x2"
D
3/4" D 2"x1-1/2"
PV 0417 B
6"x2" 2"
3/4"
28
1/2"
2"x1-1/2"
1/2"
3/4"
INST. PIPING
D
27
2"x1/2" 1/2"
26
CSC
25
2"x1/2"
24 23 011-D-0026
6"-LPC-011071003-101CS1P-H
1-1/2"x1"
6899 DS011-TRJR-480290
1"-BFW-011071302-106CS1P-H
FLC D 3/4" D
MIN.
21
011-AS-0002
1"-MPC-011230301-103CS1P-H
+
1"
22
DS011-TRJR-480201
TV 0233
2"x1"
20
6319
3/4"
19
011-D-0026
3"-CND-011071302-103CS1P-H
DS011-TRJR-480201
NC
18
7833
1"
011-D-0026
3"-MPC-011071302-103CS1P-H
RO 0072
DS011-TRJR-480201
+
1-1/2"-LPC-011071758-101CS1P-H
16
35
33
3/4"
6"x3"
PV 0417 A
TC 0233
1-1/2"-LPC-011071759-101CS1P-H
011-RM-058-LC
36
1-1/2"-BFW-011071305-103CS1P-H
011-DS-0003
17
37
6"-BFW-011043301-101CS1P-H
3/4" D 6"x3"
PY 0417
TT 0233
NOTE 11
V
011-SP-0041
FB LO NOTE 5
CL300
NOTE 9
011-RM-059-LC
38
2"-GAS-011071302-101CS1P-P
+
FB NOTE 5 LO
+
NOTE 13
18
17
6342
16
2"-LPC-011071755-101CS1P-H
15
15
NOTE 13
1-1/2"-LPC-011071753-101CS1P-H
TT 0246
2"
PI
0093
0249
0439
1-1/2"-MPS-011071716-103CS1P-H
TT
CL300
0249
2"
011-SM-016-MS 3/4"
7
INST. PIPING
1-1/2"-MPS-011071706-103CS1P-H 011-SM-006-MS
D
FQ 0093
6 5
5338
5324
UNIT 011 UNIT 691
1/2"
INST. PIPING NOTE 3
FT
0094
0094
PI 0377
PI
3/4" INST. PIPING
3/4"
L
PI 0270
3/4"
D
D
MIN
2217
NOTE 8 IP-1334 L
10
+
9
300 mm
INST. PIPING PI 0271
2"x1" 3/4"
3/4" NOTE 5 3/4"
3/4"
3/4"
D
MIN
D 2"-BFW-011071310-103CS1P-H
FB LO
D
011-SP-0044
8
3/4" V 3"x2" 4"-OLW-011071307-101CS1P-P
FB LO NOTE 5
CL300
2" NC
FB NOTE 5 LC 2"
7
OLW
101CS1P 103CS1P
6 5 4
MIN
3/4"
V
2" IP-1324 L
IP-1330 L
IP-1329 L
GENERAL NOTES
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
11
NOTES 16,17
1"D2" 18.90 PZV 0094 B
2
IP-1325 L
1
INTERCONNECTING
011-DS-0003 VAD. 19600.0 19.00 320.00 270.00 19.00 + FV 350.00
6"
2"-GAS-011071304-101CS1P-P
3
IP-1328 L
DS011-TRJR-480219
DESUPERHEATERS TYPE INLET STEAM kg/h OP. PRESS. barg OP. TEMP. °C in/out DES. PRESS. barg DES. TEMP. °C
6"
B.L
011-D-0018
17- PZV-0094A/B HAVE BEEN CALCULATED TAKING INTO ACCOUNT CV RATED OF TV-0233 (CV=0.31) AND ITS BY-PASS (CV=0.6).
3/4" D
12
D
1/2"
INST. PIPING
3/4"
3"-BFW-011071311-101CS1P-P
CL300
3/4"
1/2"
INST. PIPING INST. PIPING PT 0377 3/4"
INST. PIPING PI 0268
3"x2"
+
INST. PIPING
1/2"
LPS FOR UTILITY STATION SA-JER-IP691-TPIT-481066
FROM 011-D-0018 DS011-TRJR-480219
D
2"-LPS-691314311-101CS1P-H
011-D-0014 DS011-TRJR-480232
3/4"
1/2"
MPS SA-JER-IP691-TPIT-481065
1
D
1/2"
12"-MPS-691314307-103CS1P-H
2
2"-LPC-011076301-101CS1P-H
3"-MPS-011076301-103CS1P-H
2"-LPC-011078301-101CS1P-H
3
FT 0092
3/4"
2"x1"
6"-BFW-011071312-106CS1P-H
MIN
FI 0092
4
FT 0093
INST. PIPING FI
3/4" V
+
4"x3"
0269 MPS
INST. PIPING
FI 0093
20"-LPS-691314311-101CS1P-H
011-RM-055-LC
1-1/2"-LPC-011071755-101CS1P-H
2"
NOTE 5 LO FB
1500 mm
H
TT 0251
0094
2" CL900
3"-GAS-011071303-101CS1P-P
DWA SA-JER-IP691-TPIT-481057
TI 0246
TI
FY
2"-DWA-691305307-101SROP-N
011-RM-053-LC
FY 0092
FY
H
+
PZV 0094 A
BFW SA-JER-IP691-TPIT-481063
FQ 0092
10
INST. PIPING 3/4"
TT 0253
6"-BFW-691304306-106CS1P-H
011-RM-054-LC
1-1/2"-LPC-011071754-101CS1P-H
3/4"
4"x3"
13
1"D2" 18.90
900 mm
0266
11
3/4"
NOTES 16,17
DWA
PI
1-1/2"-LPC-011071756-101CS1P-H
TI 0251
CND SA-JER-IP691-TPIT-481061
011-RM-056-LC
L
PT 0267
MIN
INST. PIPING
INST. PIPING PI 0267
NOTE 1
BFW
3/4"
CND PUMPED CONDENSATE
0265
L
14
TI 0253
FQ 0094
3"-CND-691317303-103CS1P-H
1-1/2"-LPC-011071752-101CS1P-H
INST. PIPING
PT
LPS
PI 0265
LPS SA-JER-IP691-TPIT-481066
011-RM-052-LC
1-1/2"-LPC-011071745-101CS1P-H
12"-MPS-011071301-103CS1P-H
011-RM-045-LC
12
8
NOTE 14,15
4"P6" 14.39
39
0196
MIN
NOTE 12
9
6"x4"
40
N
20"
20"
+
2"-BFW-011071313-106CS1P-H
NOTE 7
19
13
CL300
PZV 0062 B
FLC 1-1/2"
DS011-TRJR-480204 5362
2"-LPS-011071303-101CS1P-H
DS011-TRJR-480204 5450
TO LPS HEADER
MPS LPS
DS011-TRJR-480204 5363
TO MPC HEADER
MPC
TO MPS HEADER
27
14
8"-BFW-011071001-101CS1P-P NOTE 4
V
FLC
1-1/2"-MPC-011071706-103CS1P-H
011-RM-006-MC
28
20
8"x6"
3/4"
101CS1P 106CS1P 0-50%
011-RM-005-MC
6"-LPC-011071301-101CS1P-H
3"-MPC-011071301-103CS1P-H
1-1/2"-MPC-011071705-103CS1P-H
3"-MPC-011071301-103CS1P-H
21
2"-DWA-011071302-101SR0P-N
NOTE 10 011-SC-0049 3/4"-BFW-011071304-101CS1P-H SC TYPE 7 INST. PIPING PT 0417 3/4"
1-1/2"-MPS-011071705-103CS1P-H
011-SM-005-MS
29
22
10823
6"-BFW-011071301-101CS1P-H 6"-LPC-011071301-101CS1P-H
30
23
LPC FROM HEADER DS011-TRJR-480206
NOTE 5 LO FB
3/4" V
6"x4" 3/4"
12"-MPS-011071302-103CS1P-H
24
PZV 0062 A
2"-DWA-011071302-101SR0P-N
31
25
4"-GAS-011071301-101CS1P-P
+
MIN
26
+
500 mm
DS011-TRJR-480204 5358
1-1/2"-MPC-011071707-103CS1P-H
011-RM-007-MC
DS011-TRJR-480204 5361
103CS1P 106CS1P
32
TO LPC HEADER
33
LPC
34
DS011-TRJR-480204 5359
BFW
35
10824
TO BFW HEADER
TO DWA HEADER
DWA
36
DS011-TRJR-480204 5371
12"-MPS-011071302-103CS1P-H
38 37
MPC FROM HEADER DS011-TRJR-480206
2164
6"-BFW-011071301-101CS1P-H
39
2163
TO LPS HEADER
4"P6" 14.39
NOTE 14,15
41
1000 mm
5453
DWA TO DISTRIBUTION DS011-TRJR-480206
900 mm
2161
LPS
BFW TO DISTRIBUTION DS011-TRJR-480206
3"-CND-011071302-103CS1P-H
40
LPS TO DISTRIBUTION DS011-TRJR-480206
2"-LPS-011071303-101CS1P-H NOTE 7
011-DS-0003 MPS DESUPERHEATER
MPS TO DISTRIBUTION DS011-TRJR-480206
6"-OLW-011071306-101CS1P-P
41
1- EACH INSTRUMENT TAG NUMBER IS PRECEDED BY 011 (EX. 011-TT-0001). POS. DESCRIPTION 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 5- IP`S INFORMATION OF TWIN UNIT CAN BE FOUND IN P&ID SA-JER-DS011-TRJR-480144. 3 COOLING WATER NOTES 4 POTABLE WATER 5 DEMI WATER 2, 6 DELETED 1- TO ATM AT SAFE LOCATION. 6 N.A. 3- MAIN ISOLATING VALVE IS PROVIDED WITH AN INTERNAL 1" BYPASS. 7 N.A. 4- MECHANICAL LINK. 8 N.A. 5- BLOCK VALVE SHALL BE INSTALLED WITH THE STEM IN OR BELOW THE HORIZONTAL POSITION. 9 HP STEAM 7- FOR UTILITY STATIONS DIAGRAMS REFER TO SA-JER-DS011-TRJR-480306 THROUGH 480310. 10 MP STEAM 8- MAIN ISOLATING VALVE IS PROVIDED WITH AN INTERNAL 2" BYPASS. 11 LP STEAM 9- CONTROL VALVE SUPPLIES BY DESUPERHEATER VENDOR 12 HP CONDENSATE 10- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SAJER-DS011-480274 13 MP CONDENSATE 11- MINIMUN DISTANCE REQUIRED TO TEMP. SENSOR(TT-0233) 10m 12- REQUIRED 1.5m OF STRAIGHT LENGHT PIPE UPSTREAM 011-DS-0003 AND 5m DOWNSTREAM 14 LP CONDENSATE 13- CHECK VALVE TO BE LOCATED AT HIGHEST POINT AS CLOSE AS POSIBLE TO CONDENSATE RETURN HEADER 15 BFW 14- SET PRESSURE READJUSTED BASED ON DISTANCE FROM TOP OF PIPE TO PZV-0062 A/B. ELEVATION DIFFERENCE SHOULD NOT BE HIGHER THAN 6.5m 16 PLANT AIR 15- PZV-0062A/B SIZE HAVE BEEN CALCULATED TAKING INTO ACCOUNT Cv RATED OF PV-0417(Cv=49) AND ITS BY-PASS(Cv=42) 17 INSTRUMENT AIR 16- SET PRESSURE BASED ON A MAXIMUM PZV ELEVATION OF 1.5 m FROM DESUPERHEATER NOZZLE. 18 N.A.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
RDP / MAC
JAL
00
30-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MRM / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 MPS, LPS, LPC, BFW, CND, DWA, MPC UTILITY DISTRIBUTION
011-074 011-076 Item Tags :
011-075 011-080
011-DS-0003
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480202.pid
Discipline: PRO
SA-JER-DS011-TRJR-480202 2271-011-PID-0021-071
REV:
05
Sheet: 5 of 7
SCALE: NONE Format:
A1
011-RM-070-LC
011-RM-032-LC
011-RM-031-LC
011-RM-069-LC
011-RM-027-LC
011-RM-028-LC
011-RM-029-LC
011-RM-030-LC
011-RM-023-LC
011-RM-024-LC
011-RM-025-LC
011-RM-026-LC
011-RM-036-LC
011-RM-014-LC
011-RM-035-LC
1-1/2"-LPC-011071779-101CS1P-H
1-1/2"-LPC-011071732-101CS1P-H
35 34 33 32
2"x1-1/2"
1-1/2"-LPC-011071731-101CS1P-H
1-1/2"-LPC-011071769-101CS1P-H
1-1/2"-LPC-011071727-101CS1P-H
1-1/2"-LPC-011071728-101CS1P-H
1-1/2"-LPC-011071729-101CS1P-H
36
31
BFW
6"-BFW-011071301-101CS1P-H
6"-LPC-011071301-101CS1P-H
LPC
LPC
24 23
TO LPC HEADER
25
DS011-TRJR-480205 5466
26
MPC
LPS
15
NOTE 2
LPS
2"-LPS-011071303-101CS1P-H NOTE 4
LPS 14 13
011-SC-0046
011-D-0024
DS011-TRJR-480274
DS011-TRJR-480084
9396
6398
1-1/2"-MPS-011071715-103CS1P-H
8 7
8"-MPS-011032301-103CS1P-H
1-1/2"-MPS-011071714-103CS1P-H
9
011-SM-015-MS
2 1
15
11
011-SM-014-MS
3
2"-MPC-011032301-103CS1P-H
3/4"-LPS-011200303-101CS1P-H
8
4
16
10
9
5
17
13
10
6
20
12
11
7
21
14
2"x1-1/2"
12
DS011-TRJR-480205 5468
3"-MPC-011071301-103CS1P-H
MIN.
16
D
22
18
MPC
17
FROM MPS HEADER
3/4"
25
19
DS011-TRJR-480205 5454
18
MPS
12"-MPS-011071302-103CS1P-H
MPS
TO UTIL.STAT.HEADER
3/4"
MIN.
19
NOTE 5
MIN
20
26
23
16"-LPS-011071301-101CS1P-H
LPS
27
24
22 21
DS011-TRJR-480205 5465
28
DS011-TRJR-480205 5467
MIN
BFW
29
DS011-TRJR-480205 5469
2"-DWA-011071302-101SR0P-N
FROM BFW HEADER
D
FROM LPS HEADER
D
30
TO MPC HEADER
3/4"
DS011-TRJR-480205 5464
3/4"
FROM DWA HEADER
D
28 27
39 38
DWA
D
DWA
1-1/2"-LPC-011071730-101CS1P-H
1-1/2"-LPC-011071723-101CS1P-H
1-1/2"-LPC-011071724-101CS1P-H
1-1/2"-LPC-011071725-101CS1P-H
3/4"
2"x1-1/2"
3/4"
2"x1-1/2"
1-1/2"-LPC-011071726-101CS1P-H
1-1/2"-LPS-011071790-101CS1P-H
1-1/2"-LPS-011071730-101CS1P-H 2"x1-1/2"
2"x1-1/2"
1-1/2"-LPS-011071729-101CS1P-H
1-1/2"-LPS-011071743-101CS1P-H
1-1/2"-LPS-011071714-101CS1P-H 2"x1-1/2"
1-1/2"-LPS-011071728-101CS1P-H
1-1/2"-LPS-011071727-101CS1P-H
1-1/2"-LPS-011071726-101CS1P-H
1-1/2"-LPS-011071725-101CS1P-H
1"-BFW-011029301-101CS1P-H
2"-MPC-011028301-103CS1P-H
1-1/2"-MPC-011071713-103CS1P-H
1-1/2"-MPC-011071715-103CS1P-H
1-1/2"-MPC-011071714-103CS1P-H
2"-MPC-011071304-103CS1P-H
1-1/2"-LPS-011071724-101CS1P-H
N
37
2"x1-1/2"
2185
1-1/2"-LPC-011071735-101CS1P-H
6185
1-1/2"-LPC-011071736-101CS1P-H
2186
1-1/2"-LPC-011071714-101CS1P-H
DS011-TRJR-480120
1-1/2"-LPC-011071712-101CS1P-H
011-F-0002
DS011-TRJR-480079
2"x1-1/2"
30
2"x1-1/2"
31
1-1/2"-LPS-011071723-101CS1P-H
1-1/2"-LPS-011071722-101CS1P-H
32
1-1/2"-LPS-011071721-101CS1P-H
33
1-1/2"-LPS-011071733-101CS1P-H
34
1-1/2"-LPS-011071734-101CS1P-H
1-1/2"-LPS-011071710-101CS1P-H
35
011-RM-012-LC
011-SM-073-LS
011-SM-030-LS
011-SM-029-LS
011-SM-043-LS
011-SM-014-LS
011-SM-028-LS
011-SM-027-LS
011-SM-026-LS
011-SM-025-LS 011-DS-0002
DS011-TRJR-480139
D
36
29
011-RM-013-MC
3/4"
011-D-0019
12"-LPS-011050301-101CS1P-H NOTE 1
37
011-RM-015-MC
011-RM-014-MC
011-SM-024-LS
011-SM-023-LS
38
011-SM-022-LS
39
011-SM-021-LS
40
011-SM-033-LS
40
011-SM-034-LS
41
011-SM-010-LS
41
6 5 4 3 2
011-D-0024
1
DS011-TRJR-480084 2187
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
RDP/MAC
JAL
00
29-JAN-2010
IFD
ARV/STG
RDP/MAC
JAL
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 2, 3 DELETED 1- SNUFFING STEAM 4- FOR UTILITY STATIONS DRAWINGS REFER TO SA-JER-DS011-TRJR-480303 THROUGH 480310. 5- CHECK VALVE TO BE LOCATED AT HIGHEST POINT AS CLOSE AS POSSIBLE TO CONDENSATE RETURN HEADER.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
IFD: ISSUE FOR DESIGN
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 MPS, LPS, LPC, BFW, CND, DWA, MPC UTILITY DISTRIBUTION ORIGINAL SIGNED IN PROJECT FILE
Item Tags :
011-075 011-080
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480203 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480203 2271-011-PID-0021-071
REV: 05
Sheet: 1 of 7
SCALE: NONE Format:
A1
40
40
39
39
011-AT-0003/0004
011-F-0001
011-D-0019
011-F-0002
DS011-TRJR-480042
DS011-TRJR-480042
DS011-TRJR-480121
DS011-TRJR-480117
DS011-TRJR-480139
DS011-TRJR-480139
DS011-TRJR-480121
LPS TO DISTRIBUTION DS011-TRJR-480206
6378
2190
11719
2213
2183
2184
2155
2162
36 35
32 31
16"-LPS-011071301-101CS1P-H
DS011-TRJR-480202 5358
BFW B.L. TO LPC HEADER
DS011-TRJR-480202 5359
25
23
19
1-1/2"-LPS-011071755-101CS1P-H
011-SM-055-LS
1-1/2"-LPS-011071757-101CS1P-H
FROM LPS HEADER
TO MPC HEADER
LPS
011-SM-044-LS
011-D-0001
011-D-0001
DS011-TRJR-480011
DS011-TRJR-480011
6077
4902
12 11 10
8 7 6 5 4 3
011-D-0002
011-D-0002
DS011-TRJR-480012
DS011-TRJR-480012
4911
6401
011-SM-053-LS
2
1
1
011-C-0003
011-C-0002
011-C-0004
LPS B.L.
DS011-TRJR-480081
DS011-TRJR-480044
DS011-TRJR-480052
FROM LPS HEADER
2152
2189
2149
DS011-TRJR-480202 5361
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MRM / FBL
RDP / MAC
JAL
00
29-JAN-2010
IFD
IFD: ISSUED FOR DESIGN
MCG / FBL
RDP /MAC
JAL
PREPARED BY
CHECKED BY
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1- SUPERHEATING STEAM 2- SNUFFING STEAM 3- DILUTION STEAM. 4- FOR UTILITY STATIONS DRAWINGS REFER TO SA-JER-DS011-TRJR-480306 THROUGH 480310. 5- DELETED.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
15
9
011-SM-057-LS
1-1/2"-LPS-011071753-101CS1P-H
16
13
3"-LPS-011007303-101CS1P-H
1-1/2"-LPS-011071744-101CS1P-H
3"-LPS-011006301-101CS1P-H
011-SM-059-LS
3"-LPS-011007301-101CS1P-H
2"-LPS-011071753-101CS1P-H
1-1/2"-LPS-011071759-101CS1P-H
2216
2"-LPS-011076302-101CS1P-H
3"-LPS-011006304-101CS1P-H
20"-LPS-011071301-101CS1P-H
011-SM-063-LS 011-D-0018
1-1/2"-LPS-011071740-101CS1P-H
MIN.
011-SM-040-LS
1-1/2"-LPS-011071739-101CS1P-H 011-SM-039-LS
1-1/2"-LPS-011071738-101CS1P-H 011-SM-038-LS
1-1/2"-LPS-011071767-101CS1P-H 011-SM-067-LS
1-1/2"-LPS-011071742-101CS1P-H 011-SM-042-LS
4"-LPS-011022301-101CS1P-H
1-1/2"-LPS-011071737-101CS1P-H 011-SM-037-LS
1-1/2"-LPS-011071701-101CS1P-H 011-SM-001-LS
1-1/2"-LPS-011071741-101CS1P-H 011-SM-041-LS
1-1/2"-LPS-011071769-101CS1P-H 011-SM-069-LS
1-1/2"-LPS-011071703-101CS1P-H 011-SM-003-LS
1-1/2"-MPS-011071707-103CS1P-H 011-SM-007-MS
1-1/2"-MPS-011071708-103CS1P-H 011-SM-008-MS
1-1/2"-MPS-011071709-103CS1P-H 011-SM-009-MS
1-1/2"-MPS-011071710-103CS1P-H
1-1/2"-LPS-011071731-101CS1P-H
1-1/2"-LPS-011071732-101CS1P-H
1-1/2"-LPS-011071735-101CS1P-H
4"-MPS-011018301-103CS1P-H
011-SM-010-MS
2
011-SM-031-LS
3
011-SM-013-MS
4
011-SM-032-LS
5
011-SM-035-LS
6
1-1/2"-LPS-011071791-101CS1P-H
7
011-SM-074-LS
8
1-1/2"-LPS-011071763-101CS1P-H
17
14
2"-LPS-011071303-101CS1P-H
NOTE 4
9
DS011-TRJR-480202 5363
MPC B.L.
3"-MPC-011071301-103CS1P-H
DS011-TRJR-480202 5362
MPS B.L.
011-SM-064-LS
FROM MPS HEADER
18
12"-MPS-011071302-103CS1P-H
4"-MPS-011030301-103CS1P-H
2"-LPS-011071303-101CS1P-H
20
DS011-TRJR-480202 5450
2"x1-1/2"
2"x1-1/2"
TO MPS HEADER
1-1/2"-LPS-011071764-101CS1P-H
12"-MPS-011071302-103CS1P-H
1-1/2"-MPS-011071713-103CS1P-H
DS011-TRJR-480313 5449
LPS
TO UTIL.STAT.HEADER
10
26
24
5337
011-D-0014
MIN
3"-MPC-011071301-103CS1P-H
12 11
DS011-TRJR-480313 5368
MPS DS011-TRJR-480313 5369
FROM MPC HEADER
13
MPC
14
27
21
18
15
28
22
2"-LPS-011078301-101CS1P-H
16
29
20"x16"
19
17
LPC B.L.
6"-LPC-011071301-101CS1P-H
DS011-TRJR-480232
20
DS011-TRJR-480313 5367
TO LPS HEADER
LPS
21
30
6"-BFW-011071301-101CS1P-H
6"-LPC-011071301-101CS1P-H
22
DWA B.L.
2"x1-1/2"
2"-DWA-011071302-101SR0P-N
NOTE 3
6"-BFW-011071301-101CS1P-H
FROM DWA HEADER
20"x12"
FROM BFW HEADER
8"-LPS-011051301-101CS1P-H
1-1/2"-MPS-011071711-103CS1P-H
10"-MPS-011028301-103CS1P-H
8"-MPS-011028302-103CS1P-H
12"-LPS-011047301-101CS1P-H NOTE 2
33
MIN.
TO BFW HEADER
DS011-TRJR-480313 5364
BFW DS011-TRJR-480313 5365
23
FROM LPC HEADER
24
LPC
25
34
2"-DWA-011071302-101SR0P-N
27 26
1-1/2"-MPS-011071712-103CS1P-H
DS011-TRJR-480313 5373
DWA
28
TO DWA HEADER
31
1"x3/4"
32
1"-LPS-011071792-101CS1P-H
33
12"-LPS-011017301-101CS1P-H NOTE 1
1"-BFW-011017301-101CS1P-H
34
DS011-TRJR-480202 5371
011-E-0041
35
29
37
011-F-0001
36
30
N
011-DS-0001
DS011-TRJR-480219
37
38
12"-LPS-011071301-101CS1P-H
38
011-SM-011-MS
41
011-SM-012-MS
41
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-078
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 MPS, LPS, LPC, BFW, CND, DWA, MPC UTILITY DISTRIBUTION
Item Tags :
011-075 011-080
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480204.pid
Discipline: PRO
SA-JER-DS011-TRJR-480204 2271-011-PID-0021-071
REV:
05
Sheet: 4 of 7
SCALE: NONE Format:
A1
41
011-RM-071-LC
40 39
38
N
1-1/2"-LPC-011071780-101CS1P-H
3"-LPC-011051301-101CS1P-H
8
3
FROM LPS HEADER
DS011-TRJR-480313 5460
LPS FROM MPS HEADER
DS011-TRJR-480313 5459
MPC DS011-TRJR-480313 5452
UTIL.STAT.HEADER
DS011-TRJR-480313 5462
BFW
TO LPC HEADER
LPC MPS LPS FROM
20
17 16 15 14 13 12 11 10 9 8
6
011-RM-008-MC
011-RM-009-MC
011-RM-010-MC
011-RM-011-MC
011-RM-012-MC
2"-DWA-011079301-101SR0P-N
4
21
7
2"-DWA-011034302-101SR0P-N
5
22
18
7 6
25
19
1-1/2"-MPC-011071708-103CS1P-H
9
1-1/2"-MPC-011071709-103CS1P-H
10
1-1/2"-MPC-011071710-103CS1P-H
11
1-1/2"-MPC-011071711-103CS1P-H
MIN.
26
23
3"-MPC-011071301-103CS1P-H
12
27
24
16"-LPS-011071301-101CS1P-H
2"-LPS-011071303-101CS1P-H NOTE 1
FROM BFW HEADER
28
DS011-TRJR-480313 5461
NOTE 2
TO BFW HEADER TO LPS HEADER
29
TO MPC HEADER
DWA
2"-DWA-011071302-101SR0P-N
30
DS011-TRJR-480313 5458
D
31 DS011-TRJR-480313 5463
2"x1-1/2"
1-1/2"-LPC-011071734-101CS1P-H
1-1/2"-LPC-011071733-101CS1P-H
1-1/2"-LPC-011071766-101CS1P-H
1-1/2"-LPC-011071703-101CS1P-H
2"x1-1/2"
1-1/2"-LPC-011071738-101CS1P-H
1-1/2"-LPC-011071737-101CS1P-H
1-1/2"-LPC-011071715-101CS1P-H
1-1/2"-LPC-011071717-101CS1P-H
1-1/2"-LPC-011071716-101CS1P-H
1-1/2"-LPC-011071719-101CS1P-H
1-1/2"-LPC-011071720-101CS1P-H
4"x2"
D
32
6"-BFW-011071301-101CS1P-H
1-1/2"-MPC-011071712-103CS1P-H
MPC DS011-TRJR-480203 5454
13
TO UTIL.STAT. HEADER
14
LPS
15
3/4"
33
12"-MPS-011071302-103CS1P-H
17 16
3/4"
34
DS011-TRJR-480203 5467
LPS TO MPS HEADER
18
DS011-TRJR-480203 5468
19
MPS
20
35
6"-LPC-011071301-101CS1P-H
22 21
D
36
2156
DS011-TRJR-480203 5469
FROM LPC HEADER
23
DS011-TRJR-480203 5466
24
LPC
25
D
D
37
DS011-TRJR-480121
DS011-TRJR-480203 5465
BFW
27 26
3/4"
011-E-0041
MIN.
FROM MPC HEADER
28
TO DWA HEADER
29
DWA
30
DS011-TRJR-480203 5464
31
3/4"
3/4"
2"x1-1/2"
32
2"x1-1/2"
33
1-1/2"-LPC-011071710-101CS1P-H
34
1-1/2"-LPC-011071709-101CS1P-H
8"-MPS-011016301-103CS1P-H NOTE 3
35
1-1/2"-LPC-011071711-101CS1P-H
36
2"x1-1/2"
2215
1-1/2"-LPC-011071708-101CS1P-H
1-1/2"-LPC-011071707-101CS1P-H
DS011-TRJR-480030
2"x1-1/2"
011-F-0001
37
38
FROM DWA HEADER
011-RM-034-LC
011-RM-033-LC
011-RM-066-LC
011-RM-003-LC
011-RM-038-LC
011-RM-037-LC
011-RM-015-LC
011-RM-017-LC
011-RM-016-LC
011-RM-019-LC
011-RM-020-LC
011-RM-010-LC
011-RM-009-LC
39
011-RM-011-LC
40
011-RM-008-LC
011-RM-007-LC
41
5 4 3
2
2
1
1 011-D-0009
011-D-0025
DS011-TRJR-480089
DS011-TRJR-480233
2148
2150
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / STG
RDP/MAC
JAL
00
29-JAN-2010
IFD
IFD: ISSUE FOR DESIGN
MCG/STG
RDP/MAC
JAL
PREPARED BY
CHECKED BY
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 ( EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- FOR UTILITY STATION DRAWING REFER TO SA-JER-DS011-TRJR-480306 THROUGH 480310. 2- CHECK VALVE TO BE LOCATED AT HIGHEST POINT AS CLOSE AS POSSIBLE TO CONDENSATE RETURN HEADER 3- EMERGENCY STEAM.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 MPS, LPS, LPC, BFW, CND, DWA, MPC UTILITY DISTRIBUTION ORIGINAL SIGNED IN PROJECT FILE
Item Tags :
011-075 011-080
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480205.pid
Discipline: PRO
SA-JER-DS011-TRJR-480205 2271-011-PID-0021-071
REV:
05
Sheet: 2 of 7
SCALE: NONE Format:
A1
41
41
40
40
N
011-SM-0001-MS
39 38 37
39 38 37
36
36
35
35
011-RM-004-MC
28
011-RM-002-MC 27
1-1/2"-MPC-011071703-103CS1P-H
011-RM-047-LC
1-1/2"-MPC-011071704-103CS1P-H
1-1/2"-MPC-011071702-103CS1P-H
D
2"x1-1/2"
29
011-RM-003-MC
2"x1-1/2"
011-SM-052-LS
33 32 31 30
28
1-1/2"-LPC-011071762-101CS1P-H
011-RM-062-LC D
1-1/2"-LPS-011071752-101CS1P-H 2"x1-1/2"
29
MIN.
3/4"
30
1-1/2"-LPC-011071747-101CS1P-H 2"x1-1/2"
2"-DWA-011071302-101SR0P-N
011-RM-049-LC
31
3/4"
011-RM-001-MC
1-1/2"-LPC-011071749-101CS1P-H
34
011-SM-051-LS
6"-BFW-011071301-101CS1P-H
32
12"-LPS-011071301-101CS1P-H
1-1/2"-MPS-011071701-103CS1P-H
33
1-1/2"-MPC-011071701-103CS1P-H
12"-MPS-011071302-103CS1P-H
1-1/2"-LPS-011071751-101CS1P-H
34
011-RM-061-LC
26
27
1"x3/4"
1"
1-1/2"-LPC-011071761-101CS1P-H
011-SC-0008
3/4"-LPS-011200301-101CS1P-H
DS011-TRJR-480274
26
7811
25
25 011-C-0001
24
24
4"-MPS-011011301-103CS1P-H
DS011-TRJR-480020 2177
23
23
22
22
21
21
20
20
19
011-C-0001
19
011-D-0011
12"-LPS-011040301-101CS1P-H
6"-MPS-011011302-103CS1P-H
DS011-TRJR-480142
DS011-TRJR-480105
2173
2166
18
18
17
17
16
16
011-D-0011
3"-BFW-011040301-101CS1P-H
DS011-TRJR-480105
15
15
2167
14
14
1-1/2"-MPS-011071703-103CS1P-H
011-SM-003-MS 13
011-SM-004-MS
12
13
2"x1-1/2"
1-1/2"-MPS-011071704-103CS1P-H
MIN. DS011-TRJR-480128
1-1/2"-MPS-011071702-103CS1P-H
011-SM-002-MS
11
12
011-X-0006
1-1/2"-DWA-011054301-101SR0P-N
6984
11
10
10
9
011-AS-0002
MIN 1"-MPS-011230301-103CS1P-H
1-1/2"-LPS-011071766-101CS1P-H
DS011-TRJR-480290
8
9
MIN. 011-D-0010
2"-BFW-011052301-101CS1P-H
011-SM-066-LS
DS011-TRJR-480122
6320
8
2165
1-1/2"-LPS-011071765-101CS1P-H 7
011-SM-065-LS
7
4
4
3
3
6"-BFW-011071301-101CS1P-H
2"-LPS-011071303-101CS1P-H NOTE 1
1
12"-LPS-011071301-101CS1P-H
2
2"-DWA-011071302-101SR0P-N
5
12"-MPS-011071302-103CS1P-H
5
6"-LPC-011071301-101CS1P-H
6
3"-MPC-011071301-103CS1P-H
6
2 1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
MPC TO LPC HEADER DS011-TRJR-480202
LPC TO LPC HEADER DS011-TRJR-480202
MPS FROM HEADER DS011-TRJR-480202
LPS FROM HEADER DS011-TRJR-480204
LPS FROM US LPS HEADER DS011-TRJR-480202
BFW FROM HEADER DS011-TRJR-480202
DWA FROM HEADER DS011-TRJR-480202
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / FBL
RDP / MAC
JAL
10824
10823
2161
2162
5453
2163
2164
00
29-JAN-2010
IFD
IFD: ISSUED FOR DESIGN
IRG / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1- FOR UTILITY STATIONS DRAWINGS REFER TO SA-JER-DS011-TRJR-480306 TRHROUGH 480310.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-078 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 MPS, LPS, LPC, BFW, CND, DWA, MPC UTILITY DISTRIBUTION ORIGINAL SIGNED IN PROJECT FILE
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480206.pid
Discipline: PRO
SA-JER-DS011-TRJR-480206 2271-011-PID-0021-071
REV:
05
Sheet: 6 of 7
SCALE: NONE Format:
A1
41 40
40"-CWS-011072301-301FE0W-N 011-E-0036
011-E-0036
011-E-0025
011-E-026/27/28
011-E-0021
011-E-0021
DS011-TRJR-480092
DS011-TRJR-480092
DS011-TRJR-480082
DS011-TRJR-480085
DS011-TRJR-480049
DS011-TRJR-480049
4700
4701
4702
4704
4706
4705
38
6"
32
101CS1P
AG 101CS1P 011-E-0023 DS011-TRJR-480058
37
UG 301FE0W
10"-CWS-011025301-101CS1P-N
36
10"-CWS-011072307-301FE0W-N
4708
011-E-0029
35
4"-CWR-011072306-301FE0W-N
DS011-TRJR-480098
34
AG 101CS1P
4709 011-E-0029 DS011-TRJR-480098
12"-CWR-011072308-301FE0W-N
6"-CWS-011072314-301FE0W-N
27
28"-CWR-011072309-301FE0W-N
28
28"-CWS-011072309-301FE0W-N
29
4"-CWS-011072312-301FE0W-N
30
6"
39
10"-CWR-011072307-301F0W-N
33
4"-CWS-011072306-301FE0W-N AG 101CS1P 6"
UG 301FE0W
AG 101CS1P 6" NOTE 2
UG 301FE0W
NOTE 2
011-E-0035
UG 301FE0W
4"-CWS-011037301-101CS1P-N
4710
AG UG
101CS1P 301FE0W
4"-CWR-011072312-301FE0W-N
31
101CS1P
NOTE 2
N
4707
12"-CWR-011020301-101CS1P-N
NOTE 2
12"-CWS-011020301-101CS1P-N
D
12"-CWS-011072308-301FE0W-N
33
D
2"
6"-CWR-011072314-301FE0W-N
34
2"
28"-CWR-011032301-101CS1P-N
35
4"-CWS-011035302-101CS1P-N
4"-CWR-011035302-101CS1P-N
36
40
38 011-E-0023 DS011-TRJR-480058
37
28"-CWS-011031301-101CS1P-N
39
41
40"-CWR-011072301-301FE0W-N
32 31
6"-CWR-011072313-301FE0W-N
30
6"-CWS-011072313-301FE0W-N 29 28
6"-CWR-011072305-301FE0W-N
DS011-TRJR-480062
AG 101CS1P
4711 011-E-0035
26
DS011-TRJR-480062
UG 301FE0W
6"-CWS-011025303-101CS1P-N
27
6"-CWS-011072305-301FE0W-N
26
4712
25
25 011-E-0034
24
6"-CWR-011072304-301FE0W-N
DS011-TRJR-480060
AG 101CS1P
4713
23
011-E-0034 DS011-TRJR-480060
22 21
6"-CWS-011025302-101CS1P-N
23
6"-CWS-011072304-301FE0W-N
22
4714
011-E-0033
21
12"-CWR-011072303-301FE0W-N
DS011-TRJR-480109
20
24
UG 301FE0W
AG 101CS1P
4715 011-E-0033
19
DS011-TRJR-480109
20
UG 301FE0W
12"-CWS-011042301-101CS1P-N
12"-CWS-011072303-301FE0W-N
19
4716
18
18
101CS1P 301FE0W
4677
18"-CWR-011072302-301FE0W-N
16 15 011-E-0037
14
18"-CWS-011072302-301FE0W-N
DS011-TRJR-480136 4678
13
FI 0095
12
2"
FT 0095
17
40"-CWR-011072301-301FE0W-N
18"-CWR-011098301-101CS1P-N
DS011-TRJR-480136
40"-CWS-011072301-301FE0W-N
011-E-0037
17
16 15 14 13 12
NOTE 3 TYPE 1
11
PI 0272
10
L
INST. PIPING
PT 0272
2"
2"
0254
0254
2"
5 4
8 7
2"
TI 0468
6 5
2"
2"
D
D
4 3
UNIT 011 301FE0W
3
9
PI 0274
PIPING INST. CL300
TT
INSTRUMENT PIT
6
TI
CL300
7
INSTRUMENT PIT
0273
2 1
2
B.L. UNIT 691 301FE0P
IP-6042 S
40"-CWR-691307306-301FE0P-N SA-JER-IP691-TPIT-481054
IP-6041 S
SA-JER-IP691-TPIT-481054
40"-CWS-691307306-301FE0P-N
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PRECEDED BY 011 (EX. 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 5- IPS INFORMATION OF TWIN UNIT CAN BE FOUND IN PID SA-JER-DS091-TRJR-480144.
NOTES 1 DELETED. 2- FUTURE CONNECTION. 3- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS011-TRJR-480273
1
B.L.
INTERCONNECTING
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
10
SC
2"
PI 8
011-SC-0047
2"-CWR-011072301-301FE0W-N
9
11
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR/ STG
AVS / MAC
JAL
01
11-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
RDP / MAC
JAL
00
30-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JMV / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CWS, CWR UTILITY DISTRIBUTION ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480207.pid
Discipline: PRO
SA-JER-DS011-TRJR-480207 2271-011-PID-0021-072
REV:
05
Sheet: 1 of 1
SCALE: NONE Format:
A1
41
41
MIN.
40
38
NOTES 3, 4, 5
37
EYEWASH AND SAFETY SHOWER TO 011-G-0004A/B AREA 011-SP-0106
D CSO
1-1/2"-POW-011073308-301CG0W-F
2"x1-1/2"
301CG0W 301PU0W
NOTE 2
39
40
3/4"
AG
36
39 38
N
UG
37 36
2"-POW-011073303-301PU0W-N 011-D-0013
2"-RWA-011040301-301CG0W-N
35
35
DS011-TRJR-480105
2"-RWA-011073303-301CG0W-N
MIN.
4718
34
34
2"-POW-011073312-301PU0W-N 33
3/4"
D
CSO
UG AG
CSO
UG
301PU0W 301CG0W 2"x1-1/2"
AG
CSO
301PU0W 301CG0W 2"x1-1/2"
UG AG
CSO
301PU0W 301CG0W
AG 2"x1-1/2"
UG AG
2"x1-1/2"
CSO
2"-RWA-011073301-301CG0W-N
32
EYEWASH AND SAFETY SHOWER TO 011-X-0005 011-SP-0107
1-1/2"-POW-011073316-301CG0W-F
301PU0W 301CG0W
301PU0W 301CG0W 2"x1-1/2"
MIN.
UG AG
UG
2"-POW-011073306-301PU0W-N 2"-POW-011073305-301PU0W-N
2"-POW-011073313-301PU0W-N
MIN.
SWA NOTE 2
30
301PU0W 301CG0W 2"x1-1/2"
MIN.
MIN.
31
2"-POW-011073304-301PU0W-N
MIN.
2"-POW-011073318-301PU0W-N
32
29
33
2"-POW-011073301-301PU0W-N
31 30
CSO
29
MIN.
27
27
PI
17
N/A
011-SP-0102
0201
0201
011-SP-0103
N/A
N/A
011-SP-0104
N/A
N/A
DS011-TRJR-480274
0200
0200
011-SP-0106
0202
0202
011-SP-0107
N/A
N/A
DS011-TRJR-480274
011-SP-0108
N/A
N/A
9390
011-SP-0109
0203
0203
011-SC-0010
9 8 7
301PU0W 301CG0W
011-SP-0109
2"x1-1/2"
3/4"-RWA-011200303-301CG0W-N
011-SC-0062
3/4"-RWA-011200320-301CG0W-N
20
MIN.
19 18 17
011-SC-0063
3/4"-RWA-011200325-301CG0W-N
2"
PIPING INST
PT 0413
PI 0413
16
9385
L
15 14
011-SC-0023
3/4"-RWA-011200309-301CG0W-N
DS011-TRJR-480273
13
9384
LO 3/4"
D
12
3/4"
D
11
D
2" LC
10 9
2"x3/4"
7
9391
3/4"
2"
3/4"
D
D
D
UNIT 011
5 4
6 5 4
LO
3
B.L.
3
B.L. UNIT 691
2 1
IP-6126 S
IP-5012 S
2 1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
RDP / MAC
JAL
30-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
00 REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PRECEDED BY 011 (EX. 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 5- PID INFORMATION OF TWIN UNIT CAN BE FOUND IN PID SA-JER-DS011-TRJR-480144.
NOTES 1, DELETED. 2- FOR UTILITY STATIONS DRAWINGS REFER TO SA-JER-DS011-TRJR-480306 THROUGH 480310. 3- PWA LINES ABOVE GROUND LENGTH TO BE MINIMIZED. 4- PWA LINES TO SAFETY SHOWERS AND EYEWASH FACILITIES SHALL BE INSULATED AGAINST SOLAR RADIATION. 5- PWA LINES ABOVE GROUND TO BE INSULATED ( COLD). 6- FOR SAFETY SHOWER TYPICAL DETAILS REFER TO DWG: SA-JER-DSAAA-TRJR-480014.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
NOTES 3, 4, 5
8
DS011-TRJR-480274
6
3/4"-RWA-011200305-301CG0W-N
9389
011-SP-0105
INST PIPING
3/4"-RWA-011200307-301CG0W-N
9388
011-SC-0016
L
21
MIN.
N/A
0379
EYEWASH AND SAFETY SHOWER
1-1/2"-POW-011073320-301CG0W-F
LO
011-SP-0101
DS011-TRJR-480274
CSO
SA-JER-IP691-TPIT-481053
10
011-FAH-XXXX
0379
2"
2"-PWA-691310318-301PU0W-N
11
011-FSH-XXXX
PT
MIN.
12
ALARMS 011-SC-0018
MIN.
PI 0281
3/4"
FI 0099
13
SAFETY SHOWER
PI
NOTES 3, 4, 5
DS011-TRJR-480274
2"-RWA-691311312-301FE0W-N
14
9387
NOTE 6
24
INST
3/4"
INST PIPING
DS011-TRJR-480274
EYEWASH AND SAFETY SHOWER 011-SP-0108
1-1/2"-POW-011073307-301CG0W-F
0280 3/4"-RWA-011200317-301CG0W-N
2"-RWA-011073303-301CG0W-N
15
25
23
AG
UG
PIPING
2"
26
22
FI 0100
011-SC-0049
2"-POW-011073321-301PU0W-N
EYEWASH AND SAFETY SHOWER TO DESALTERS AREA 011-SP-0101
18
16
2"-POW-011073301-301PU0W-N
EYEWASH AND SAFETY SHOWER TO 011-G-0007 A/B AREA 011-SP-0103
INSTRUMENT PIT
011-SP-0104
EYEWASH AND SAFETY SHOWER TO 011-G-0017A/B AREA 011-SP-0105
UG
INSTRUMENT PIT
19
EYEWASH AND SAFETY SHOWER 011-G-0005A/B AREA 011-SP-0102
AG
301CG0W 301FE0W
20
301PU0W 301CG0W
2"-POW-011073302-301PU0W-N UG AG CSO 2"x1-1/2"
21
EYEWASH AND SAFETY SHOWER
SUBSTATION BUILDING
2"-RWA-011073303-301CG0W-N
SA-JER-IP691-TPIT-481052
22
2"-POW-011073315-301PU0W-N
2"-RWA-011073302-301FE0W-N
23
1-1/2"-POW-011073309-301CG0W-F
24
1-1/2"-POW-011073311-301CG0W-F
25
1-1/2"-POW-011073310-301CG0W-F
26
1-1/2"-POW-011073317-301CG0W-F
28
1-1/2"-POW-011073319-301CG0W-F
28
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
JMV / STG
REVISION MEMO
PREPARED BY
RDP / MAC CHECKED BY
JAL APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PWA, SWA UTILITY DISTRIBUTION ORIGINAL SIGNED IN PROJECT FILE
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480209.pid
Discipline: PRO
SA-JER-DS011-TRJR-480209 2271-011-PID-0021-073
REV:
05
Sheet: 1 of 1
SCALE: NONE Format:
A1
41
41
40
40
39
39
38 37
N
LOW PRESSURE NITROGEN
UTILITY AIR
INSTRUMENT AIR
TO HEADER
TO HEADER
TO HEADER
DS011-TRJR-480212 6248
DS011-TRJR-480212 6247
DS011-TRJR-480212 6249
38 37
36
36
35
35
MIN.
MIN. 1"-N2L-011230302-101CS1P-N
34
011-AS-0002
1"-IAI-011230302-301CG2P-N
DS011-TRJR-480290
011-AS-0002
34
DS011-TRJR-480290
6252
6251
33
33
MIN.
32
32
2"-N2L-011043301-101CS1P-N 31
011-D-0007 DS011-TRJR-480112
31
6244
MIN.
30
30
NOTE 4 1"
29
29
1"-IAI-011230306-301CG2P-N 28
IAI 011-G-0002 A/B DS011-TRJR-480257
28
10798
1"
27
27
26
26
1"-IAI-011230304-301CG2P-N
25
IAI 011-G-0001 A/B DS011-TRJR-480255
25
10799
24
24
1"
22 21
19 18 17 16
INST. PIPING
4"-N2L-011074301-101CS1P-N
20
1"-N2L-011230301-101CS1P-N
011-AS-0001 DS011-TRJR-480289
23
3"-IAI-011074301-301CG2P-N
3"-SAI-011074301-301CG2P-N
23
22 21 20
4127
MIN.
19
MIN. 011-AS-0001
1"-IAI-011230301-301CG2P-N
18
DS011-TRJR-480289 6239
17
PI 0414
PI 0279
L
16
L
PI
15
0275
3/4" PT
14
0414 13
PI
PT
0276
0276
L
INST. PIPING
PI 0277
8
PI 0278
1/2" 1/2"
12
3/4"
11
LO
3/4"
3/4" 10
V
FI 0097
FT 0096
3/4"
3/4" D
CL300
FI 0096
9
14
0279
3/4"
INST. PIPING
10
PT
13
3/4"
12 11
INST. PIPING
FI 0098
15
9
LC
8
LO
PIPING INST.
7
7
4
D
D
MIN.
5
3/4"
MIN.
D
3/4"
6
LO
UNIT 011 UNIT 691
301CG2P 301CG1P
IP-1323
IP-1321-L
3
5
MIN.
3/4"
6
4
B.L
IP-1322
3
1
1
PLANT AIR FROM UNIT 691 SA-JER-ITF-691-TPIT-PID-481070
NITROGEN FROM UNIT 691 SA-JER-ITF-691-TPIT-PID-481074
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1,2,3 DELETED 4- INSTRUMENT AIR BRANCHES EVERY 6M.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
INSTRUMENT AIR FROM UNIT 691 SA-JER-ITF-691-TPIT-PID-481071
2
INTERCONNECTING
2
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / FBL
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JVM / FBL
RDP / MAC
JAL
00
29-JAN-2010
IFD
ISSUED FOR DESIGN
MVF / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY 011-078 011-074
PIPING AND INSTRUMENT DIAGRAM Project:
011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 N2L, SAI, IAI, UTILITY DISTRIBUTION
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480211 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480211 2271-011-PID-0021-074
REV: 05
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
N
37
37
36
36
35
35
34
34
33
33
MIN. 2"-N2L-011076301-101CS1P-N
32
LP.FLARE HEADER DS011-TRJR-480218
32
4094
31
31
30
011-G-0003-A
1"x1/2"
1"-IAI-011230309-301CG2P-N
1"-N2L-011171301-101CS1P-N
DS011-TRJR-480251
29
MIN.
8975
30
IAI 011-G-0004 A/B DS011-TRJR-480259
29
10800
1" 28
28 011-G-0003-B
27
1"x1/2"
1"-N2L-011171302-101CS1P-N
27
DS011-TRJR-480251 8976
26
LPN
TO LPN HEADER
18
1" 24
3"-IAI-011074302-301CG2P-N
23 22 21
20 19
25
NOTES 1, 2
3"-SAI-011074302-301CG2P-N
DS011-TRJR-480213 6300
21
TO UTA HEADER
22
UTA
23
DS011-TRJR-480213 6299
INA
24
TO INA HEADER
25
DS011-TRJR-480213 6311
26
20 19
4"-N2L-011074302-101CS1P-N
18 17
16
16
15
15
14
14
13
13
12
12
11
11
10
10
9
9
8
8
7
7
6
6
5
5
4
4
2 1
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- TIPICAL INSTRUMENT SUBHEADER CONNECTION. 2- INSTRUMENT AIR BRANCHES EVERY 6M.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
3
3"-IAI-011074301-301CG2P-N
3
3"-SAI-011074301-301CG2P-N
4"-N2L-011074301-101CS1P-N
17
LOW PRESSURE
UTILITY AIR
INSTRUMENT AIR
NITROGEN HEADER
TO HEADER
TO HEADER
DS011-TRJR-480211 6248
DS011-TRJR-480211 6247
DS011-TRJR-480211 6249
2 1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / STG
RDP / MAC
JAL
00
29-JAN-2010
IFD
IFD: ISSUED FOR DESIGN
IRG / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY 011-078 011-074
PIPING AND INSTRUMENT DIAGRAM Project:
011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 N2L, SAI, IAI, UTILITY DISTRIBUTION
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480212.pid
Discipline: PRO
SA-JER-DS011-TRJR-480212 2271-011-PID-0021-074
REV:
05
Sheet: 2 of 3
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
37
36
36
35
35
34 33
LPN TO LPF HEADER DS011-TRJR-480221
INA TO 011-ZV-0108 DS011-TRJR-480120
INA TO 011-ZV-0019 DS011-TRJR-480106
4089
6265
6388
AIR TO FANS FILLTER
011-ALP-0001
DS011-TRJR-480270
DS011-TRJR-480291
INA TO 011-ZV-0024 DS011-TRJR-480042
7753
6271
7756
INA TO 011-ZV-0013 DS011-TRJR-480139 6278
34
N
33
32
32
31
31
30
INA TO 011-ZV-0107 DS011-TRJR-480117
INA TO 011-ZV-0003 DS011-TRJR-480030
6264
6277
30
27
1"-IAI-011220305-301CG2P-N
1"-IAI-011230303-301CG2P-N
24
1"-IAI-011220311-301CG2P-N
25
1"-IAI-011220308-301CG2P-N
26
1"-IAI-011220309-301CG2P-N
27
1"-IAI-011220302-301CG2P-N
28
1"-IAI-011220310-301CG2P-N
28
2"-IAI-011403301-301CG2P-N
29
2"-N2L-011076303-101CS1P-N
29
26 25 24
23
23
IAI
MIN.
MIN.
MIN.
10810
MIN.
1"-IAI-011230311-301CG2P-N
21
NOTE 2 3"-IAI-011074302-301CG2P-N
3"-IAI-011074302-301CG2P-N
IAI 20 FROM HEADER6311
MIN.
20
IAI 011-G-0017 A/B DS011-TRJR-480261
MIN.
MIN.
21
MIN.
22
MIN.
22
19
19
3/4"
18
18
3"-SAI-011074302-301CG2P-N
NOTE 1
SAI
SAI FROM HEADER6299 17
3"-SAI-011074302-301CG2P-N
17
3/4"
14
N2L
4"-N2L-011074302-101CS1P-N
NOTE 1
4"-N2L-011074302-101CS1P-N
N2L 15 FROM HEADER6300
MIN.
15
16
MIN.
16
3/4"
14
11
10
10
9
9
8
8
7 6 5 4 3 2 1
2"-N2L-011076302-101CS1P-N
11
4"-N2L-011018301-101CS1P-N
12
2"-N2L-011035302-101CS1P-N
12
2"-N2L-011035301-101CS1P-N
13
2"-IAI-011035301-301CG2P-N
13
7 6 5 4 3
LPN TO LPF HEADER DS011-TRJR-480221
2
DS011-TRJR-480091
LPN TO C-0002 OVER HEAD LINE DS011-TRJR-480043
4093
8261
4095
1
011-K-0001
011-K-0001
011-K-0001 SUCTION
DS011-TRJR-480264
DS011-TRJR-480264
11730
4090
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / STG
RDP / MAC
JAL
00
29-JAN-2010
IFD
IFD: ISSUED FOR DESIGN
IRG / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
APPR/AUTH BY
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- UTILITY STATION DRAWING REFER TO SA-JER-DS011-TRJR-480306 THROUGH 480309. 2- INSTRUMENT AIR BRANCHES EVERY 6m.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
REF. DWG
011-075
JUBAIL EXPORT REFINERY 011-078 011-074
PIPING AND INSTRUMENT DIAGRAM Project:
011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 N2L, SAI, IAI, UTILITY DISTRIBUTION
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480213.pid
Discipline: PRO
SA-JER-DS011-TRJR-480213 2271-011-PID-0021-074
REV:
05
Sheet: 3 of 3
SCALE: NONE Format:
A1
41
011-D-0015 FUEL GAS KO DRUM
40
41
FQ 0102
40
TRIM: FGS-011075601-101CS2P / FGS-011075602-103CS2P
NOTE 3
PI 0259
PZV 0044 A
L
ZHS
PTG
1/2"
0102 C
0102 O
0102
+
3/4" V
3/4"
3/4"
LO FB NOTE 4
INST. PIPING
12"
3/4"-FGS-011075306-101CS2P-S
V
6"
B1
2012
NOTE 2
6"
011-D-0015
29
30
1-1/2"H3" 8.50 PZV 0044 B +
011-SP-0042
CL300
NC
V
3/4"
L1B
FB LC NOTE 4
V
2"
PV 0376 +
12"x6" 6"
12"-FGS-011075309-101CS2P-H
LI
LI
0081
0082 L
0082
L
LT
8
2"
2"
1/4" D 2"
2"
7
24" ID
2" L2A
L3A
2" L1A
LT 0105
LI 0105
TT
PT
FT
0241
0261
0088
INST. PIPING
INST. PIPING
1/2"
ZLC
ZLO
ZYC
ZHA
0101
0101
0101
0101
ATM
1/2"
3/4"
OPEN POSITIONER BY-PASS
ZV 0101 +
ZLS
ZLS
ZY
ZHS
0101 C
0101 O
0101
0101
23
3/4"
22
UC
FGS FC TSO NOTES 6,7,9,13
PIPING
INST.
3/4"
21
PI 0264
20 19 18 17 16 15
12"x6"
14 13 12
2"-FGS-011075001-101CS2P-P
UC
V
B.L.
11
UNIT 011 UNIT 691
B.L. 10
MIN. 3/4"
2"
D
D1 2"
4
2"-FGS-011075307-101CS2P-N HPT
B2
NC
2"
3
101CS2P 101CS1P
2
9 8
MIN.
5
ZC 0330 ZC 0334
1/4" D
S1
1950 mm
NC
HH
2"
3/4" INST. PIPING
DE
24
12"x4" 4" 12"x4"
M1
9
IA CLOSED
0088
L
101CH2F 101CS1P
1/4" D NC
0082
0261
25
IP-1326 L
LG
H
S
3/4"
2"
1/4" D
NOTE 1
FO CL300
PIPING INST.
10
L3B
INST. PIPING
MAG
11
L2B
0241
CL300
4"
2"
26
0101
600 mm MIN.
2"
ZYV 0101
FI
NOTE 14
12" TYPE 8 NOTE 12
0409
27
NOTE 2
12"-FGS-011075301-101CS2P-H
A1
2"
0101 L
ZHSR RESET
MIN.
2"
ZC
29 2160
MIN.
2"
W1
PI
2" CL300
3/4"-FGS-011075310-101CS2P-N
INST. PIPING
MIN.
PIPING INST.
ZHXS
+
TI
28
101CH2F 101CS2P
UC
101CH2F 101CS2P
4"x1-1/2" 3/4"
29
2"-LFL-011075303-101CH2F-N HPT
2" 3/4" V NOTE 4 FB 4"x3" LO
HPT 2"-LFL-011075302-101CH2F-N
2147
FY 0088
NOTE 11
NC V
32 31
NO LOW POCKET
PI 0260
HPT
3/4"
3/4"
33
INST. PIPING
PTG
NOTE 3
MIN.
PT 0259
NC
101CH2F 101CS2P
NOTE 2
+
12"-FGS-011075302-101CS2P-S
29
29 3014
4"x1-1/2" PT 0376
3/4"-LFL-011075306-101CH2F-S
0.2%
CL300
NOTE 14
2"-PTG-011075303-101CS1P-S
3/4" V NOTE 4 FB 4"x3" LO 4"-LFL-011075301-101CH2F-N
+
H
600mm MIN.
NO POCKETS
3/4"-FGS-011075311-101CS2P-S
TO HEADER
DS011-TRJR-480215 5335
FUG
ZLS
34
MIN.
V
CL300
PC 0376
13
101CS2P 101CH2F
INTERCONNECTING
7 6 5 4
29
3
3911
NOTE 2
2
600 mm MIN.
3/4"-FGS-011075305-101CS2P-S MIN.
HPT 29
2"-LFL-011075304-101CH2F-S
3015
NOTE 2
101CS2P 101CH2F
NC
101CS2P 101CS1P
2"-OLW-011075302-101CS1P-N
2"-FGS-011075305-101CS2P-S
1
mm mm barg °C barg °C
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
RDP / MAC
JAL
00
23-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
JMV / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
OLW
UTILITIES IDENTIFICATION
GENERAL NOTES
011-D-0015 KO DRUM 2800.0 1500.0 3.50 45.00 8.50 80.00
1
3/4"-LFL-011075305-101CH2F-N
NOTE 1
3/4"-OLW-011075301-101CS1P-N
DRUM TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
ZLS
PI 0283
IP-1327 L
3/4"
3/4"
6
0102
2"-PTG-011075305-101CS1P-S
1-1/2"H3" 8.50
SC
12
0102
MIN.
NC
+
CL300
011-SC-0012
0102
35
2"-PTG-691313309-101CS1P-S SA-JER-IP691-TPIT-481068
READABLE
3/4"-PTG-011075303-101CS1P-S
14
ZHA
MIN.
101CH2F 101CS1P
MAG
2"-FGS-011075301-101CS2P-H
LI 0136
LG 0135
H
21
15
3/4" 1/2"
0088
INST. PIPING
16
ZLO
ZV 0102
INST. PIPING
FQ
NOTE 1
22
17
ZLC
NOTE 2
LT 0136
MIN.
23
BY-PASS
FC NOTES 6,7,9 TSO
4"-FGS-011075304-101CS2P-N
1/4" D 2"
18
4"x2"
PIPING INST. CL300 2"
PIPING INST. 2"
OPEN
ATM
CL300
1/4" D
CLOSED
12"FGS-691313311-101CS2P-H SA-JER-IP691-TPIT-481067
2"
24
20
INST. PIPING
4"x2"
2"-PTG-011075302-101CS1P-S
2"-PTG-011075302-101CS1P-S
FT 0102
PT 0284
CL300 2"
PIPING INST.
DE
MIN.
10"x2"
L
36
IA
0102
2"-FGS-011075312-101CS2P-H
NOTE 10
19
TT 0260
MIN.
3/4"
27
25
3/4"-LFL-011075307-101CH2F-S
NC
28
26
3/4"-PTG-011075308-101CS1P-S
0260
3914
FI
PI 0284
MIN.
101CS1P 101CH2F 2"-PTG-011075301-101CS1P-S
29
38 37
NOTE 2
MIN.
TO HEADER
29
DS011-TRJR-480215 6837
FUG
30
TI
2"-LFL-011075307-101CH2F-S
39
S
2"-FGS-011075308-101CS2P-N
2172
HPT
32 31
ZYV 0102 +
10"-PTG-011075304-101CS1P-S
33
TO HEADER
34
PIG
35
N
ZHSR RESET 0102
ZC 0406
FY 0102
2"-FGS-011076301-101CS2P-H
NOTE 10 900 mm MIN.
36
ZHXS 0102 L
DS011-TRJR-480215 5336
37
FLARE HEADER
38
DS011-TRJR-480218
39
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX. 011-TT-0001). POS. 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 2 3 5- IPS INFORMATION OF TWIN UNIT CAN BE FOUND IN PID SA-JER-DS011-TRJR-480144. 4 NOTES 5 5, 8 DELETED. 6 1- LOCAL LEVEL INDICATOR TO BE READABLE FROM MANUAL VALVE. 2- MAKE CONNECTION ON TOP OF THE PIPE. 7 3- LOCAL EMERGENCY SWITCH BEHIND FIREWALL OR IN SAFE LOCATION. 8 4- BLOCK VALVE SHALL BE INSTALLED WITH THE STEM IN OR BELOW THE HORIZONTAL POSITION. 9 7- VALVE TO BE LOCATED AT GROUND AND AT LEAST 7.5m BEYOND THE EDGE OF ANY FIRE HAZARDOUS ZONE. 10 9- EACH BATTERY LIMIT EMERGENCY SHUTDOWN VALVE SHALL HAVE A DEDICATED SAFE-LOCATION ACTUATING BUTTON. THE SAFE-LOCATION A DEDICATED 11 SAFE-LOCATION ACTUATING BUTTON. THE SAFE-LOCATION ACTUATING BUTTONS SHALL BE GROUPED TOGETHER AND INSTALLED AT GRADE AND LOCATED MORE THAN 15m FROM ANY FIRE-HAZARDOUS EQUIPMENT OR PROCESS VESSEL. SAFE LOCATION BUTTONS SHALL ALSO BE AT LEAST 7.5 m BEYOND THE EDGE 12 OF ANY FIRE-HAZARDOUS ZONE. 13 10- DRIP LEG TO BE 10" x 2000 mm (MIN), HLL=600 mm LLL=300 mm. 14 11- FOR NOZZLES DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING. 15 12- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DSG11-TRJR-480273 16 13- DELETED. 17 14- MECHANICAL LINK 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE HPW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN H.P. NITROGEN L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PTG, FGS KO DRUM
011-074 011-076 011-075 011-080
Item Tags :
011-D-0015
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480214.pid
Discipline: PRO
SA-JER-DS011-TRJR-480214 2271-011-PID-0021-074
REV:
05
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
40
40
N
39 38
011-F-0002
011-F-0002
011-F-0002
011-F-0001
011-F-0001
011-F-0001
011-F-0001
DS011-TRJR-480118
DS011-TRJR-480119
DS011-TRJR-480119
DS011-TRJR-480118
DS011-TRJR-480115
DS011-TRJR-480116
DS011-TRJR-480115
DS011-TRJR-480116
2182
2181
2179
2180
2178
2176
2175
2174 PIG
36
37
35 34
FROM PIG HEADER
011-F-0002
38
DS011-TRJR-480214 5336
37
39
36 35 34
8"-FGS-011046302-101CS2P-S
31 30
FUG
12"-FGS-011075302-101CS2P-S 27 26
FROM 011-D-0015
29 DS011-TRJR-480214 5335
28
8"-FGS-011045302-101CS2P-S
29
2"-PTG-011046301-101CS1P-S
30
2"-PTG-011045301-101CS1P-S
31
6"-FGS-011048302-101CS2P-S
32
6"-FGS-011049302-101CS2P-S
32
2"-PTG-011049301-101CS1P-S
33
2"-PTG-011048301-101CS1P-S
33
28 27 26
MIN.
2"-PTG-011075301-101CS1P-S
MIN.
PILOT GAS
MIN.
24
25
MIN.
25
24
2"-PTG-011075301-101CS1P-S
23
23
22
22
21
21 20
20
12"-FGS-011075302-101CS2P-S
12"-FGS-011075302-101CS2P-S
19
NO POCKETS
19
MIN.
FUG
17
17
16
16
15
15
14
FUG
MIN.
MIN.
FUG
2"-FGS-011075312-101CS2P-H
13 12
DS011-TRJR-480214 6837
18
FROM FUG HEADER
18
14 13 12
10
9
9
8
8
5 4 3 2
3"-FGS-011021301-101CS2P-S
6
3"-FGS-011019301-101CS2P-S
7
2"-FGS-011076302-101CS2P-H
10
2"-FGS-011034301-101CS2P-S
11
2"-FGS-011076303-101CS2P-H
11
7 6 5 4
FLARE HEADER
011-D-0016
011-D-0004
011-D-0005
FLARE HEADER
DS011-TRJR-480221
DS011-TRJR-480090
DS011-TRJR-480046
DS011-TRJR-480050
DS011-TRJR-480221
2171
7768
2169
2168
2170
3 2
1
1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
24-MAY-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / STG
RDP / MAC
JAL
00
29-JAN-2010
IFD
IFD: ISSUED FOR DESIGN
MVF / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 FGS, PTG UTILITY DISTRIBUTION ORIGINAL SIGNED IN PROJECT FILE
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480215.pid
Discipline: PRO
SA-JER-DS011-TRJR-480215 2271-011-PID-0021-075
REV:
05
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
40
40
N
41
39
39
37
37
36
36
35
35
34
34
33
33
32
32
31
31
30
30
29
29
28
0.2% CLD
6"-CLD-011078317-101CH2S-N
27 26
DS011-TRJR-480229 7841
38
FROM HEADER
38
28 27 26
MIN. 25
12 11 10
2"-CLD-011200317-101CH2S-P
6"-CLD-011078317-101CH2S-N
2"-CLD-011200318-101CH2S-P
2"-CLD-011040310-101CH2S-P
2"-CLD-011040307-101CH2S-P
2"-CLD-011040308-101CH2S-P
2"-CLD-011040301-101CH2S-P
2"-CLD-011040312-101CH2S-P
2"-CLD-011038304-101CH2S-P
2"-CLD-011038309-101CH2S-P
2"-CLD-011038307-101CH2S-P
2"-CLD-011008306-101CH2S-P
2"-CLD-011040311-101CH2S-P
2"-CLD-011008305-101CH2S-P
2"-CLD-011009304-101CH2S-P
2"-CLD-011009305-101CH2S-P
2"-CLD-011009301-101CH2S-P
2"-CLD-011009303-101CH2S-P
2"-CLD-011003317-101CH2S-P
2"-CLD-011010301-101CH2S-P
2"-CLD-011010305-101CH2S-P
2"-CLD-011010304-101CH2S-P
2"-CLD-011009306-101CH2S-P
2"-CLD-011009307-101CH2S-P
2"-CLD-011010313-101CH2S-P
2"-CLD-011010311-101CH2S-P
2"-CLD-011010306-101CH2S-P
13
101CH2S 101CS1P
2"-CLD-011010310-101CH2S-P
14
2"-FLO-011078315-101CS1P-N
15
2"-CLD-011010309-101CH2S-P
16
2"-CLD-011010308-101CH2S-P
4"
UG AG
4"
UG AG
22
UG AG
21
2"-CLD-011004305-101CH2S-P
2"-CLD-011004304-101CH2S-P
2"-CLD-011004309-101CH2S-P
4"
4" 4"
UG AG
2"-CLD-011008309-101CH2S-P
UG AG
2"-CLD-011004301-101CH2S-P
4"
2"-CLD-011004307-101CH2S-P
UG AG
2"-CLD-011004310-101CH2S-P
4"
4"
4"
4"
4"
4"
UG AG
2"-CLD-011003315-101CH2S-P
3/4" D
17
2"-CLD-011009308-101CH2S-P
18
UG AG
2"-CLD-011003309-101CH2S-P
AG
UG AG
AG
UG AG
2"-CLD-011003310-101CH2S-P
UG AG
UG
2"-CLD-011003312-101CH2S-P
UG
UG AG
2"-CLD-011042302-101CH2S-P
4" UG AG
UG AG
2"-CLD-011043301-101CH2S-P
UG AG
4"
UG AG
4"
UG AG
4"
UG AG
4"
UG AG
4"
UG AG
4"
UG AG
4"
UG AG
4"
UG AG
4"
UG AG
4"
UG AG
4"
UG AG
4"
UG AG
4"
0.2% AG
UG AG
4"
UG
4"
UG AG
4"
UG AG
4"
UG AG
4"
UG AG
4"
UG AG
19
4"
20
4"
21
4"
22
23
4"
23
24
2"-CLD-011078340-101CH2S-N
24
25
0.2%
6"-CLD-011078318-101CH2S-N
20 19 18 17 16 15 14
011-E-0032
011-E-0005
011-E-0005
011-E-0006
011-E-0007 A/B
011-E-0007-C/D
DS011-TRJR-480107
DS011-TRJR-480006
DS011-TRJR-480006
DS011-TRJR-480007
DS011-TRJR-480008
DS011-TRJR-480008
5429
5294
7717
5299
5315
2525
12 11
011-E-0014-F
011-E-0014-E
011-E-0014-B
011-E-0012
011-E-0013
011-E-0013
011-E-0012
011-E-011-B
011-E-0010-B
011-E-0010-B
011-PV-0338
011-TV-0175
011-E-0031
011-SC-0024
011-E-0024
011-E-0006
011-TV-0024
011-E-0007-A/B
DS011-TRJR-480019
DS011-TRJR-480019
DS011-TRJR-480019
DS011-TRJR-480017
DS011-TRJR-480018
DS011-TRJR-480018
DS011-TRJR-480017
DS011-TRJR-480017
DS011-TRJR-480016
DS011-TRJR-480016
DS011-TRJR-480100
DS011-TRJR-480104
DS011-TRJR-480104
DS011-TRJR-480274
DS011-TRJR-480110
DS011-TRJR-480007
DS011-TRJR-480008
DS011-TRJR-480008
5676
5677
5669
5654
4929
6074
5652
2605
2606
4997
5002
2602
9395
5417
5301
7845
2524
6067
10
9
9 FLO 011-E-0014-E
011-E-0014-C
011-E-0014-B
011-E-0012
011-E-0013
DS011-TRJR-480019
DS011-TRJR-480019
DS011-TRJR-480019
DS011-TRJR-480017
DS011-TRJR-480018
5678
5667
5670
5653
011-E-0012 DS011-TRJR-480017
6064
4925
011-E-0011
011-E-0011
RES-011040021
011-E-0030
RES-011040022
011-E-0031-B
011-E-0031
011-SC-0022
011-E-0005
DS011-TRJR-480104
DS011-TRJR-480100
DS011-TRJR-480104
DS011-TRJR-480104
DS011-TRJR-480104
DS011-TRJR-480274
011-E-0005
011-FV-0061
DS011-TRJR-480017
DS011-TRJR-480017
DS011-TRJR-480006
DS011-TRJR-480006
DS011-TRJR-480015
7840
2604
7846
2603
5415
9394
7719
6375
6988
4923
5651
7
7
4" 011-E-0005
011-E-0030-B
DS011-TRJR-480006
DS011-TRJR-480100
10777
9405
6 CLD DRAIN
6 5
8
UG AG
4
2"-CLD-011230302-101CH2S-P
3 2 1
DS011-TRJR-480231 5478
7852
TO CLD HEADER
8
13
5 4 3 2 1
011-AS-0002 DS011-TRJR-480290 6893
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
01
18-APR-2011
AFC
AFC. APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
00
22-DEC-2010
AFC
AFC. APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
PREPARED BY
CHECKED BY
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- DELETED.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS. DESCRIPTION 011-073 19 N.A. 011-072 20 FUEL OIL 011-073 21 FUEL GAS 011-071 22 N.A. 23 N.A. 24 N.A. 25 CLOSED DRAIN 26 N.A. 011-071 27 L.P. NITROGEN 011-071 28 H.P. FLARE 29 L.P. FLARE 011-071 30 SOUR/ACID FLARE 011-071 31 PILOT GAS 011-071 32 AUX COOLING WATER 011-074 011-074
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY 011-078 011-074
PIPING AND INSTRUMENT DIAGRAM Project:
011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CLOSED DRAIN UTILITY DISTRIBUTION ORIGINAL SIGNED IN PROJECT FILE
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480216.pid
Discipline: PRO
SA-JER-DS011-TRJR-480216 2271-011-PID-0021-078
REV:
03
Sheet: 5 of 8
SCALE: NONE Format:
A1
36
011-PZV-0004
011-PZV-0050
011-PZV-0001
011-PZV-0002
011-PZV-0069
011-PZV-0068
DS011-TRJR-480112
DS011-TRJR-480012
DS011-TRJR-480112
DS011-TRJR-480012
DS011-TRJR-480112
DS011-TRJR-480011
DS011-TRJR-480011
DS011-TRJR-480098
DS011-TRJR-480062
2138
6361
10789
6362
2137
6069
6061
2139
2140
2"
34
RS
NOTE 1
32
3/4" 101CS2P 101CH2F
30
35 34 33 32 31 30
NC
1"
29
38
D
29
V
28
28
2"-LFL-011076305-101CH2F-H
27
27
2"-LFL-011076305-101CH2F-H
26
24"-LFL-011076301-101CH2F-N
25
44"x24"
44"-LFL-011076301-101CH2F-N
LOW PRESSURE FLARE TO 011-D-0018 PID-480219
17
8"-LFL-011001301-101CH2F-N
3"-LFL-011099301-101CH2F-N
8"-LFL-011005301-101CH2F-N
2"x1"
3/4"-LFL-011025303-101CH2F-N
18
3/4"-LFL-011025301-101CH2F-N
19
2"-LFL-011037302-101CH2F-N
20
21 20 19 18 17 16
16
3/4"-LFL-011011303-101CH2F-N
3/4"-LFL-011200304-101CH2F-N
14
15
011-SC-0040 DS011-TRJR-480274
6076
8616 011-LG-0005
3/4"-LFL-011012302-101CH2F-N
13
DS011-TRJR-480023 2082
12
011-LG-0002A/B
3/4"-LFL-011011302-101CH2F-N
DS011-TRJR-480020
11
011-SC-0027
3/4"-LFL-011200307-101CH2F-N
2066
DS011-TRJR-480275 9398
10
3/4"-LFL-011012303-101CH2F-N
9
14
1"-LFL-011007303-101CH2F-N
011-LG-0002B DS011-TRJR-480020
1"-LFL-011006303-101CH2F-N
15
25
22
6"-LFL-011078301-101CH2F-N
21
5326
23
2"-LFL-011020301-101CH2F-N
22
3/4"-LFL-011171365-101CH2F-N
23
26
24
14"-LFL-011012301-101CH2F-N
6"-LFL-011010301-101CH2F-N
24
24"-LFL-011011301-101CH2F-N
MIN.
42"-LFL-011076303-101CH2F-N
31
39
36
NC
33
N
37
101CS1P 101CH2F
FI 0091
35
011-PZV-0049
4"-LFL-011025304-101CH2F-N
37
011-PZV-0003
4"-LFL-011037301-101CH2F-N
38
011-D-0007
24"-LFL-011006302-101CH2F-N
2"-FGS-011076301-101CS2P-H
24"-LFL-011006301-101CH2F-N
39
40
2"-N2L-011076301-101CS1P-N
40
41
12"-LFL-011043303-101CH2F-N
27
24"-LFL-011007302-101CH2F-N
21
12"-LFL-011043302-101CH2F-N
4094
24"-LFL-011007301-101CH2F-N
2172
3"-LFL-011043301-101CH2F-N
41
13 12 11 10
011-LG-0007
9
DS011-TRJR-480023 4944
8
7
7
6
6
5
5
4
4
3 2 1
3/4"-LFL-011171366-101CH2F-N
3/4"-LFL-011171365-101CH2F-N
8
3
6186
03
011-A-0002
LPF HEADER
011-D-0014
011-LG-0149
011-LG-0159
011-A-0005
011-A-0003
DS011-TRJR-480019
DS011-TRJR-480251
DS011-TRJR-480048
DS011-TRJR-480220
DS011-TRJR-480232
DS011-TRJR-480011
DS011-TRJR-480012
DS011-TRJR-480097
DS011-TRJR-480059
6972
2039
2040
8618
2041
2158
2141
6288
6387
4989
6393
5- CONECTION OF PZV OUTLET PIPING TO FLARE HEADER SHALL BE DONE AT 45º TIE-IN THE FLOWING DIRECTION OF THE FLARE HEADER.
NOTES 1- SPOOL PIECE.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
4792
30-SEP-2011
011-G-0003-B
4- PZV OUTLET LINE CONTROL VALVE AND INSTRUMENT AND EQUIPMENT VENT LINES SHALL BE CONNECTED ON TOP OF PIPE.
DS011-TRJR-480001
8288
04
011-PZV-0007 0008 DS011-TRJR-480023
3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED.
DS011-TRJR-480225
6060
DS011-TRJR-480061
8617
2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
DS011-TRJR-480010
AB
DS011-TRJR-480251
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001).
011-PZV-0078A/B
13-MAR-2013
011-A-0004
GENERAL NOTES
011-PZV-0093
05
011-G-0003-A
011-PZV-0005A/C 0006 DS011-TRJR-480020
011-E-0014A/D
011-TZV-0013
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MRM / STG
RDP / MAC
JAL
00
29-JAN-2010
IFD
ISSUED FOR DESIGN
NPS / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS.
2
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY 011-078 011-074
PIPING AND INSTRUMENT DIAGRAM Project:
011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 LPF UTILITY DISTRIBUTION
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480218 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480218 2271-011-PID-0021-076
REV: 05
Sheet: 1 of 4
SCALE: NONE Format:
A1
41
011-D-0018 LP FLARE KO DRUM
41
40
TRIM: LFL-011076601-101CH2S / SLP-011076601-103CH2S INSULATION: H
40
39
3/4"-LFL-011076302-101CH2F-N
0.2%
44"-LFL-011076301-101CH2F-N
38
N
38
44"x32"
44"x32"
37
39
37
HPT 36
0.2%
44"-LFL-011076001-101CH2F-N
31
PI 0293
30
2"
PT 0294
PIPING INST.
2"
PIPING INST.
NC
011-D-0018
M1
LOW PRESSURE FLARE 5326FROM HEADER 25 PID-480218
NOTE 16
24" ID
T2
2"
2"-LPS-011076303-101CS1P-H
1/2"
1/2"
2"
PIPING
3/4" 2"x3/4" NC
17
TT
TT
0264
0265
6"-SLP-011076001-103CH2S-P
16
TI
H
TI
0264
L
0265
HH LL
15
6"-SLP-011076006-103CH2S-P 14
MIN. S
D1
6
6"x2"
3/4" NOTE 8
3" V
101CH2S 101CS1P
M
011-G-0026-B
NOTE 19 1"x3/4" 3/4"-SLP-011076008-103CH2S-P
2"
2"
MIN
2"
UC
2"-SLP-011076003-103CH2S-P 3/4"
D
4"-OLW-011076301-101CS1P-N
OLW
NOTE 7
OLW
3/4"
MG
ZC
0026 A
0359
3/4"
LPT 8"x4"
NOTE 8
M
011-G-0026-A
NOTE 19 1"x3/4" 3/4"-SLP-011076007-103CH2S-P
2"
2"
2"
2"
TI
CL300
8"-SLP-011076005-101CH2S-P
3/4"
FLO 8285
OLW
21 20 19 18
3/4"-LFL-011200309-101CH2F-N
DS011-TRJR-480274
17
7885 FUEL GAS FROM DISTRIBUTION HEADER DS011-TRJR-480214
FUEL GAS FROM DISTRIBUTION HEADER DS011-TRJR-480214
2147
2160
16 15 14
2" 13
2"
2"-SLP-011076004-103CH2S-P
UC
MCC
103CH2S 101CS2P
2"-CLD-011076302-101CS2P-P
10"x8" 101CH2S 101CS1P
10"x8"
D
103CH2S 101CS1P
MG
ZC
FLO
0026 B
0359
8286
12
NOTE 17 UNIT 011 UNIT 691
10
B.L.
9 8 7
25
INTERCONNECTING
6 5 4 3 2
5325
OLW 1
25 5323
LO FB
B.L.
0263
MIN
3/4"
MIN.
NOTE 7
NOTE 5
3/4" 8"-SLP-011076004-103CH2S-P
PIPING
TYP 4
250 mm MIN.
103CH2S 101CS2P
2"-CLD-011076303-101CS2P-P
1
250 mm MIN.
3/4"-OLW-011076304-101CS1P-N
2
2217
MIN.
INST
INST PIPING
101CS1P 103CH2S
MCC
MIN.
3/4"-OLW-011076303-101CS1P-N
3
TYP. 4
103CH2S 101CS1P
UC
INST. PIPING
10
22
D
2"-SLP-011076007-103CH2S-P
2"-FLO-011076302-101CS1P-N
101CS1P 103CH2S
4
2"
011-SC-0039
PI 0304
6"x2"
2"-SLP-011076008-103CH2S-P 5
NC
3/4"
2"x3/4"
NOTE 9
3/4"
3"-MPS-011076301-103CS1P-H
3"-SLP-011076012-103CH2S-H
2"-CLD-011076301-101CH2S-P
7
PIPING LPT 8"x4"
MIN
8
PIPING
24
L
11
NOTE 6 8"-SLP-011076003-103CH2S-P
INST
25
H
LI 0106
V
103CH2S 101CH2S
3/4"
2"-SLP-011076008-103CH2S-P
9
0307 INST
NOTE 9 10
MIN.
PI
PI 0290
2"-FLO-011076301-101CS1P-N
NOTE 6
PI 0291
MIN.
11
3/4"
LT 0106
NOTE 4
MIN
MIN.
3/4"
2"
MIN.
DS011-TRJR-480136 3597
LPT
2"-SLP-011076007-103CH2S-P
2"
103CH2S 101CH2S
TO SLOP HEADER
ZC 0359
23
0359
LPT
SLOP
LI 0088 LL
ZC
13 12
4"
B2 10"
2"
LT 0088
IP-1331L 0.2%
2"x3/4"
INST
18
3/4" D
6490
PT 0292
D
3/4"
LG 0087
44"-LFL-691306301-101CH2F-N SA-JER-IP691-TPIT-481076
FT 0104
NOTE 3
MAG
1/4"
2"
5324
20
L2A 2"
E2
27
MIN.
2"x1"
28
2" CL300
TT 0266
1/4" 2"
2"
2216
2"x1" 1"
2"-LPC-011076301-101CS1P-H
14
21
11
TI 0266
3/4"-OLW-011076302-101CS1P-N
0104
E1
4"-SLP-011076010-101CH2S-P
0292
2"-LPS-011076302-101CS1P-H
10"-SLP-011076002-101CH2S-P
FI
PIPING INST.
MIN.
Z 0008
PI
30
26
1/4" 2"
PIPING INST. 2" L1A 2" 2" L3A 2"
2"
31
NOTE 2 CL300
29
250 mm MIN.
23
PI 0444
L3B 2"
24" ID
T1
19
1/4" 2"
L1B 2"
24
22
32" A2 2"
V1
P2
M2
2"
FT 0105
V
4"
L2B 2"
26
33
3/4"
2"
NOTE 11
27
FI 0105
3/4"-SLP-011076009-101CH2S-P
P1
34
32
MIN.
44" B1
2"
32" A1
3/4" INST. PIPING
29 28
PT 0295
2"-LFL-011075303-101CH2F-N
32
PI 0295
TH
33
PI 0294
0.2%
34
35
32"-LFL-011076301-101CH2F-N
32"-LFL-011076301-101CH2F-N
35
2"-LFL-011075302-101CH2F-N
V
103CH2S 103CS1P
36
011-G-0026-A / B LP FLARE KO DRUM PUMPS
8"-SLP-011076002-101CH2S-P
INSULATION: N
25
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
RDP / MAC
JAL
00
13-JAN-2010
IFD
IFD: ISSUED FOR DESIGN
JVM / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
5322
GENERAL NOTES
NOTES 20- SYMMETRICAL ARRANGEMENT
DRUM TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
mm mm barg °C barg °C
011-D-0018 KO DRUM 13500.0 4500.0 0.20 40.00 3.50 400.00
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
m³/h barg bar barg °C kg/m³
011-G-0026-A / B CENTRIFUGAL 80.0 9.40 8.90 23.00 40.00 1000.0
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
NOTE 18
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX. 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAIN SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER NOTES 4 POTABLE WATER 12,13,14,15, 21 DELETED 5 DEMI WATER 1- EMERGENCY SHUTDOWN PUSH BUTTON SHALL BE LOCATED IN SAFE AREA. 6 N.A. 2- THERMAL FLOWMETER. 3- MAIN PUMP STARTING UPON OPERATOR ACTION, BOTH PUMPS TRIPS UPON LOW LOW SET POINT. 7 N.A. 4- PUMPS WILL STOP IF THE TEMPERATURE IN D-0018 IS GREATER THAN 170ºC, TAHH -0265 (PERMISSIVE) OR LESS THAN 25ºC, TALL -0265 (PERMISSIVE). 8 N.A. 5- SPECIFIC NITROGEN UTILITY CONNECTION. 9 HP STEAM 6- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 10 MP STEAM 7- DISMOUNTABLE PIPING FOR POSSIBLE CLEAN OUT BY STEAM INJECTION. 8- PROVIDE STRAIGHT LENGTH OF PIPE OF AT LEAST 5 TIMES THE SUCTION NOZZLE DIAMETER INMEDIATELY UPSTREAM OF THE NOZZLE. 11 LP STEAM 9- CHECK VALVE SHALL BE INSTALLED HORIZONTALLY. 12 HP CONDENSATE 10- MAKE CONNECTION ON TOP. 13 MP CONDENSATE 11- WEAR PLATE. 14 LP CONDENSATE 16- FOR NOZZLES DETAIL ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING. 15 BFW 17- B.L. VALVE WITH STEM IN HORIZONTAL. 18- OPERATION TEMPERATURE: AMB TO 200º C 16 PLANT AIR 19- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JER-DS011-TRJR-480249. 17 INSTRUMENT AIR 18 N.A.
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 LPF UTILITY DISTRIBUTION
011-074 011-076 Item Tags :
011-075 011-080
011-D-0018, 011-G-0026A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480219.pid
Discipline: PRO
SA-JER-DS011-TRJR-480219 2271-011-PID-0021-076
REV:
05
Sheet: 2 of 4
SCALE: NONE Format:
A1
41
41 LPF HEADER DS011-TRJR-480218
40
40
2158 011-PZV-0011A/B/C/0012
011-PV-0033A
011-LG-0023
011-LG-0025
011-PV-0033B
DS011-TRJR-480046
DS011-TRJR-480046
DS011-TRJR-480046
DS011-TRJR-480046
DS011-TRJR-480046
2016
2023
9399
2017
6982
5410
6983
6981
3969
36 35 34
3"-LFL-011021302-101CH2F-N
DS011-TRJR-480045
37
011-SC-0006 DS011-TRJR-480275
20"-LFL-011019302-101CH2F-N
011-A-0001
2"-LFL-011019303-101CH2F-N
011-D-0005 DS011-TRJR-480050
6"-LFL-011019301-101CH2F-N
38
011-D-0004 DS011-TRJR-480046
3/4"-LFL-011200306-101CH2F-N
39
36
3/4"-LFL-011019304-101CH2F-N
35 34
3/4"-LFL-011019305-101CH2F-N 33
3/4"-LFL-011019307-101CH2F-N 011-G-0011-B
3/4"-LFL-011171355-101CH2F-N
32
32
DS011-TRJR-480250
DS011-TRJR-480275
8970
1"x3/4"
28 27
23 22 21
011-G-0013-A
011-G-0013-B
DS011-TRJR-480250
DS011-TRJR-480250
8968
8967
20
42"-LFL-011076303-101CH2F-N
19 18 17 16 15 PIG-011075304
3/4"-LFL-011171320-101CH2F-N
3914
12
011-LG-0041
27
011-G-0012-B
24 23 22 21 011-PZV-0015
011-PZV-0014
011-PZV-0015
DS011-TRJR-480050
DS011-TRJR-480050
DS011-TRJR-480050
6826
2024
6825
20
3/4"-LFL-011021305-101CH2F-N
19
011-PV-0038A DS011-TRJR-480050
3/4"-LFL-011021306-101CH2F-N
6951
18
011-PV-0038B
17
DS011-TRJR-480050 6952
16
011-LG-0031
15
011-G-0012-B
3/4"-LFL-011021304-101CH2F-N
DS011-TRJR-480263
DS011-TRJR-480050
8622
5051
14
011-D-0006
13
2"-LFL-011075307-101CH2F-S 3/4"-LFL-011171319-101CH2F-N
011-G-0012-A
3/4"-LFL-011044301-101CH2F-N
DS011-TRJR-480263
DS011-TRJR-480113
8625
5012
12
3/4"-LFL-011024302-101CH2F-N 1"x3/4"
DS011-TRJR-480056 2077
3/4"-LFL-011171317-101CH2F-N
011-G-0012-A
2"-LFL-011002301-101CH2F-N
DS011-TRJR-480263
11
2"-NAP-011002004 DS011-TRJR-480004
8624 011-LG-0037
25
2025
8623
3/4"-LFL-011171318-101CH2F-N
011-LG-0029 DS011-TRJR-480050
DS011-TRJR-480263
DS011-TRJR-480214
13
28
3/4"-LFL-011021303-101CH2F-N
20"-LFL-011019302-101CH2F-N
24
29
26
6"-LFL-011019301-101CH2F-N
25
30
3/4"-LFL-011171357-101CH2F-N
3/4"-LFL-011171356-101CH2F-N
26
31
9400
10"-LFL-011021307-101CH2F-N
DS011-TRJR-480250
29
3/4"-LFL-011021308-101CH2F-N
10"-LFL-011021301-101CH2F-N
011-G-0011-A
3/4"-LFL-011171354-101CH2F-N
30
011-SC-0028
3/4"-LFL-011200308-101CH2F-N
8969
31
10
37
3/4"-LFL-011019306-101CH2F-N
33
11
38
N
6"x3"
14
39
5243
3/4"-LFL-011023301-101CH2F-N
10
DS011-TRJR-480054
9
2076
8
011-LG-0035
42"-LFL-011018301-101CH2F-N
9
PZV-0046A/G-0047 DS011-TRJR-480043
3/4"-LFL-011022301-101CH2F-N
42"x36"
DS011-TRJR-480052
7
42"-LFL-011018301-101CH2F-N
1"x3/4"
6955
3/4"-LFL-011171305-101CH2F-N
011-G-0010-A DS011-TRJR-480246 8610
2"-LFL-011024301-101CH2F-N
6
8
2037
3/4"-LFL-011171315-101CH2F-N
3/4"-LFL-011030304-101CH2F-N
7
011-LG-0043
011-LG-0011
3/4"-LFL-011018302-101CH2F-N
DS011-TRJR-480080
DS011-TRJR-480043
2105
011-G-0010-A
6
2071
DS011-TRJR-480246
5
5
011-LG-0014
3/4"-LFL-011018303-101CH2F-N
8611
DS011-TRJR-480044 011-PZV-0044
4
DS011-TRJR-480214
4"-LFL-011075301-101CH2F-N
3/4"-LFL-011171306-101CH2F-N
3014
011-G-0010-B
3/4"-LFL-011030305-101CH2F-N
011-LG-0045
DS011-TRJR-480246
DS011-TRJR-480080
8613
2106
5045
3
DS011-TRJR-480044 011-D-0015
2
011-LG-0019
1"-LFL-011018310-101CH2F-N
3
4
2"-LFL-011075304-101CH2F-S
36"-LFL-011076303-101CH2F-N
3/4"-LFL-011171316-101CH2F-N
011-G-0010-B DS011-TRJR-480246
DS011-TRJR-480214
3/4"-LFL-011030302-101CH2F-N
2
DS011-TRJR-480081
8612
3015
2075
011-LG-0047
011-LG-0017
3/4"-LFL-011018304-101CH2F-N
2107
DS011-TRJR-480044
1 011-LG-0081 DS011-TRJR-480214
1"-LFL-011030303-101CH2F-N
3/4"-LFL-011075306-101CH2F-S
DS011-TRJR-480081 2108
0.2%
2012
011-SC-0012
26"-LFL-011030301-101CH2F-N
26"-LFL-011030301-101CH2F-N
3/4"-LFL-011200305-101CH2F-N
PZV-0019-A/C/0020
DS011-TRJR-480274
DS011-TRJR-480080
05
13-MAR-2013
AB
7814
2102
04
30-SEP-2011
03 011-PV-0376
1
2072
011-LG-0049
3/4"-LFL-011075305-101CH2F-N
DS011-TRJR-480214 3911 LPF HEADER DS011-TRJR-480221 2157
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
RDP / MAC
JAL
00
29-JAN-2010
IFD
IFD: ISSUED FOR DESIGN
JGT / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- PZV OUTLET LINE CONTROL VALVE AND INSTRUMENT AND EQUIPMENT VENT LINES SHALL BE CONNECTED ON TOP OF PIPE. 4- THE CONNECTION OF PZV OUTLET PIPING TO THE FLARE HEADER SHALL BE BONE AT 45º TIE-IN THE FLOWING DIRECTION OF THE FLARE HEADER.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
AB: AS BUILT
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 LPF UTILITY DISTRIBUTION ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480220 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480220 2271-011-PID-0021-076
REV: 05
Sheet: 3 of 4
SCALE: NONE Format:
A1
41
41 LPF HEADER DS011-TRJR-480220
40
40
2157
39
39
N
38
0.2% 37
38
12"-LFL-011076304-101CH2F-N
37
36
36
011-PZV-0075
3"-LFL-011013301-101CH2F-N
DS011-TRJR-480141
35 34
3"-LFL-011039301-101CH2F-N
33
4"-LFL-011036304-101CH2F-N
2014
35
011-PZV-0070
34
0.2%
DS011-TRJR-480102 2063
011-ZV-0029
33
DS011-TRJR-480094 011-LG-0061
2018
1"-LFL-011034306-101CH2F-N
32
32
DS011-TRJR-480089 2008
36"-LFL-011076303-101CH2F-N
31 30 29 28 27
31
011-D-0025
4"-LFL-011079301-101CH2F-N
DS011-TRJR-480233 011-LG-0134
3/4"-LFL-011079302-101CH2F-N
30
2033
DS011-TRJR-480233
29
3956
1"-LFL-011033302-101CH2F-N 28 BY-PASS 011-PZV-0024/0025 DS011-TRJR-480086
1"-LFL-011033306-101CH2F-N
6738
10"-LFL-011033307-101CH2F-N
26
27 011-PZV-0025
26
DS011-TRJR-480086 011-PZV-0024
10"-LFL-011033301-101CH2F-N
6737
DS011-TRJR-480086
25
25 011-LG-0073
2060
1"-LFL-011036306-101CH2F-N
DS011-TRJR-480094
24
2011
1"-LFL-011036303-101CH2F-N
DS011-TRJR-480094
23
3/4"-LFL-011171361-101CH2F-N
22
011-G-0015-A DS011-TRJR-480253
3/4"-LFL-011171362-101CH2F-N
6"-LFL-011034302-101CH2F-N
011-G-0015-B
DS011-TRJR-480086
DS011-TRJR-480094
011-LT-0097
1"-LFL-011034305-101CH2F-N
011-G-0015-B
011-PZV-0087
DS011-TRJR-480090
DS011-TRJR-480087
2059
3"-LFL-011033305-101CH2F-N 12"
17 001-LG-0059
1"-LFL-011033302-101CH2F-N 011-PZV-0086
DS011-TRJR-480086
DS011-TRJR-480087
2061
3"-LFL-011033304-101CH2F-N 011-G-0016-A
6184
1"-LFL-011034301-101CH2F-N
DS011-TRJR-480247
3/4"-LFL-011171332-101CH2F-N
16 15
011-PV-0308
1"-LFL-011034301-101CH2F-N
DS011-TRJR-480090
8615
13
18
6775
16
14
19
2062
2015
8609
3/4"-LFL-011171331-101CH2F-N
20
011-LG-0056
3/4"-LFL-011033303-101CH2F-N
011-PZV-0033/0034
4"-LFL-011036301-101CH2F-N
DS011-TRJR-480253
15
21
5032
2042
8608
17
22
DS011-TRJR-480090
DS011-TRJR-480253
3/4"-LFL-011171364-101CH2F-N
011-PV-0072
011-PZV-0048
8607
18
1"-LFL-011032302-101CH2F-N
DS011-TRJR-480084
011-G-0015-A
20 19
23
DS011-TRJR-480090 6828
DS011-TRJR-480253
3/4"-LFL-011171363-101CH2F-N
2010
011-PZV-0055
6"-LFL-011034307-101CH2F-N
8606
21
4978
011-G-0016-B
1"-LFL-011036307-101CH2F-N
8614
13
DS011-TRJR-480093
011-ZV-0028
4"-LFL-011035303-101CH2F-N
14
011-LG-0071
DS011-TRJR-480247
2046
DS011-TRJR-480091
12
3/4"-LFL-011200303-101CH2F-N
6407
12
011-SC-0025 DS011-TRJR-480274
11
11
7812
011-PZV-0551
6"-LFL-011035304-101CH2F-N
DS011-TRJR-480091
10 9
6"-LFL-011035301-101CH2F-N
6406
10
011-PZV-0550
9
DS011-TRJR-480091
8
8
2022
2"-LFL-011035302-101CH2F-N
2"-LFL-011035302-101CH2F-N
011-K-0001 DS011-TRJR-480091
7
7
2021
6
1"-LFL-011035305-101CH2F-N
011-K-0001
2"-LFL-011035309-101CH2F-N
DS011-TRJR-480264
6412
6769
1
1"
27 4089
D
1"
6770
3
FI 0103
NC
NC
NC
RS
3/4"
NOTE 1
2"
101CH2F 101CS1P
NC
2"
21
2"-N2L-011076302-101CS1P-N
RS
27
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR/ STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP/ STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
RDP / MAC
JAL
00
29-JAN-2009
IFD
IFD: ISSUED FOR DESIGN
VJS / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
4095
3/4" D
D
2
2170
1
2"
NOTE 1
2"-FGS-011076302-101CS2P-H
D
2"
101CS1P 101CH2F
2"-N2L-011076303-101CS1P-N
2"-LFL-011076306-101CH2F-H
2"-LFL-011076307-101CH2F-H
MIN.
2171
FI 0116
MIN.
21
2"-FGS-011076303-101CS2P-H
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- PZV OUTLET LINE CONTROL VALVE AND INSTRUMENT AND EQUIPMENT VENT LINES SHALL BE CONNECTED ON TOP OF PIPE. 5- THE CONNECTION OF PZV OUTLET PIPING TO THE FLARE HEADER SHALL BE BONE AT 45º TIE-IN THE FLOWING DIRECTION OF THE FLARE HEADER.
NOTES 1- SPOOL PIECE.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
4
DS011-TRJR-480264
101CH2F 101CS2P
101CS2P 101CH2F
3
5
011-K-0001
1"-LFL-011035306-101CH2F-N
4
6
011-K-0001
DS011-TRJR-480091
5
2
24
011-PV-0113
1"-LFL-011036303-101CH2F-N
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-072 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY 011-078
PIPING AND INSTRUMENT DIAGRAM Project:
011-074 011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 LPF UTILITY DISTRIBUTION
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480221.pid
Discipline: PRO
SA-JER-DS011-TRJR-480221 2271-011-PID-0021-076
REV:
05
Sheet: 4 of 4
SCALE: NONE Format:
A1
41
41
40
40
N
39 38
39 38
37
37
36
36
35
35
CLD SUBHEADER DS011-TRJR-480230
34
34
7871
33
32
32
31
31
2"-FLO-011078317-101CS1P-N
33
30 29 28 27
30 29 28 27
26
26
5471 FLO FROM HEADER 24
MIN.
MIN.
3/4"
23
22 21 20 19
2"-FLO-011039310-101CS1P-N
4"-FLO-011039306-101CS1P-N
D
6"-FLO-011077302-101CS1P-N
23
MIN.
24
25
6"-FLO-011077301-101CS1P-N MIN.
MIN.
25
18
HFO-011027005
22
DS011-TRJR-480103 9409
21 20 19
MIN.
18
17
17
2"-FLO-011013304-101CS1P-N 16
4"x2"
011-S-0001
16
DS011-TRJR-480141
MIN.
2230
15
15
9
2"-FLO-011078319-101CS1P-N
4"-FLO-011018302-101CS1P-N
2"-FLO-011018301-101CS1P-N
4"-FLO-011030302-101CS1P-N
4"-FLO-011037301-101CS1P-N
2"-FLO-011039302-101CS1P-N
2"-FLO-011039303-101CS1P-N
CLD HEADER DS011-TRJR-480226
2"-FLO-011039309-101CS1P-N
2"-FLO-011078309-101CS1P-N
2"-FLO-011030301-101CS1P-N
MIN.
4"-FLO-011039301-101CS1P-N
2232
4"-FLO-011013308-101CS1P-N
DS011-TRJR-480102
MIN.
4"-FLO-011039306-101CS1P-N
2"-FLO-011039304-101CS1P-N
011-S-0002
14
2"-FLO-011039308-101CS1P-N
10
2"-FLO-011013305-101CS1P-N
11
2"-FLO-011038302-101CS1P-N
12
2"-FLO-011038303-101CS1P-N
13
2"-FLO-011078304-101CS1P-N
2233
2"-FLO-011039307-101CS1P-N
2"-FLO-011039305-101CS1P-N 14
011-S-0002 SPARE FILTER DS011-TRJR-480102
13 12 11 10
7843
9
MIN.
7 6 5 4
CLD SUBHEADER
011-G-0018
011-S-0001
011-C-0003
011-G-0017
011-C-0003
011-C-0002
011-C-0002
2"-HFO-0111078345
DS011-TRJR-480099
DS011-TRJR-480226
DS011-TRJR-480103
DS011-TRJR-480141
DS011-TRJR-480081
DS011-TRJR-480101
DS011-TRJR-480080
DS011-TRJR-480044
DS011-TRJR-480043
DS011-TRJR-480231
2241
2214
2229
6379
5034
2237
6312
5409
6159
7832
2"-FLO-011078305-101CS1P-N
011-G-0016 B
8
8 7
3/4" CLD SUBHEADER
011-G-0016 A
011-G-0018
011-G-0018
011-G-0017
RES-011039004
011-G-0017
011-C-0003
DS011-TRJR-480226
DS011-TRJR-480099
DS011-TRJR-480103
DS011-TRJR-480103
DS011-TRJR-480101
DS011-TRJR-480103
DS011-TRJR-480101
DS011-TRJR-480081
2658
2240
2228
2227
2234
2220
2236
7803
6 5
NOTE 1 011-S-0001 SPARE FILTER DS011-TRJR-480141
4
2231
3
3
2
2
1
1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
RDP / MAC
JAL
00
29-JAN-2010
IFD
IFD: ISSUED FOR DESIGN
JGT / STG
RDP / MAC
JAL
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES. SYMBOLS AND DETAILS SEE DRAWING SA-JER-DSAAA-480001 THROUGH SA-JER-TRJR-480022.
NOTES 1- FOR VDU BYPASS.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 FLO UTILITY DISTRIBUTION
Item Tags :
011-075 011-080
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480222.pid
Discipline: PRO
SA-JER-DS011-TRJR-480222 2271-011-PID-0021-077
REV: 05
Sheet: 1 of 6
SCALE: NONE Format:
A1
41
41
40
40
N
39 38 37
011-E-0020
011-E-0020
2"-CLD-011078330
DS011-TRJR-480029
DS011-TRJR-480029
DS011-TRJR-480227
2300
2301
2657
2"-CLD-011078337
011-E-0020
011-E-0020
011-E-0019
011-E-0019
011-E-0019
011-E-0019
DS011-TRJR-480227
DS011-TRJR-480029
DS011-TRJR-480029
DS011-TRJR-480028
DS011-TRJR-480028
DS011-TRJR-480028
DS011-TRJR-480028
7829
2299
2298
2296
2297
2243
2244
39 38 37
2"-FLO-011015301-101CS1P-N
2"-FLO-011015302-101CS1P-N
2"-FLO-011015304-101CS1P-N
2"-FLO-011015303-101CS1P-N
32
2"-FLO-011015306-101CS1P-N
33
2"-FLO-011015305-101CS1P-N
34
2"-FLO-011078306-101CS1P-N
2"-FLO-011015308-101CS1P-N
35
2"-FLO-011078310-101CS1P-N
36
2"-FLO-011015309-101CS1P-N
36
35 34 33 32
29
28
28
27
27
3"x2"
3"-FLO-011015306-101CS1P-N
25
3"-FLO-011015304-101CS1P-N
3"x2" 3"x2"
26
MIN.
3"x2"
MIN.
3"x2"
3"x2" 3"-FLO-011015308-101CS1P-N
MIN.
MIN.
26
3"x2"
29
MIN.
30
MIN.
30
MIN.
31
MIN.
31
25
3"x2"
FLO 6"-FLO-011077301-101CS1P-N 5471 TO FLO HEADER
24 FLO FROM DISTRIBUTION 5472
6"-FLO-011077301-101CS1P-N MIN.
23
MIN.
MIN.
24
23
19
18
18
17
17
16 15 14 13
2"-FLO-011027306-101CS1P-N
19
2"-FLO-011027301-101CS1P-N
20
2"-FLO-011002301-101CS1P-N
20
2"-FLO-011002302-101CS1P-N
21
2"-FLO-011027302-101CS1P-N
21
2"-FLO-011027303-101CS1P-N
22
3/4"-FLO-011200303-101CS1P-N
22
16 15 14 13
12
12
11 10
11 011-SC-0043
011-G-0014
011-G-0014
011-E-0003
011-E-0003
011-G-0012
011-G-0012
DS011-TRJR-480273
DS011-TRJR-480066
DS011-TRJR-480066
DS011-TRJR-480004
DS011-TRJR-480004
DS011-TRJR-480065
DS011-TRJR-480065
7839
2312
2310
2256
2255
2309
6391
10
9
9
8
8
7
7
6
6
5
5
4
4
3
3
2
2
1
1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / FBL
RDP / MAC
JAL
00
29-JAN-2010
IFD
IFD: ISSUED FOR DESIGN
JGT / STG
RDP / MAC
JAL
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED.
NOTES
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 FLO UTILITY DISTRIBUTION ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480223.pid
Discipline: PRO
SA-JER-DS011-TRJR-480223 2271-011-PID-0021-077
REV:
05
Sheet: 2 of 6
SCALE: NONE Format:
A1
41
41
40
40
N
39
39
38
38
37
37
011-E-0018-C
011-E-0017-B
011-E-0018-C
011-E-0016-B
011-E-0018-A
011-E-0016-B
011-E-0017-A
011-E-0018-A
011-E-0016-A
011-E-0016-A
011-E-0018-B
011-E-0015
DS011-TRJR-480027
DS011-TRJR-480026
DS011-TRJR-480027
DS011-TRJR-480025
DS011-TRJR-480027
DS011-TRJR-480025
DS011-TRJR-480026
DS011-TRJR-480027
DS011-TRJR-480025
DS011-TRJR-480025
DS011-TRJR-480027
DS011-TRJR-480024
2258
2397
2246
2248
7763
2249
2250
7764
2247
2245
7789
36
2251
36
2"-FLO-011013309-101CS1P-N
2"-FLO-011014305-101CS1P-N
2"-FLO-011013302-101CS1P-N
2"-FLO-011013311-101CS1P-N
2"-FLO-011014302-101CS1P-N
2"-FLO-011014308-101CS1P-N
2"-FLO-011013310-101CS1P-N
31
2"-FLO-011014301-101CS1P-N
32
2"-FLO-011013303-101CS1P-N
33
2"-FLO-011014307-101CS1P-N
34
2"-FLO-011014303-101CS1P-N
35
2"-FLO-011014304-101CS1P-N
35
34 33 32 31
28
28
27
27
6"-FLO-011077301-101CS1P-N
23
DS011-TRJR-480242 5473
6"-FLO-011077301-101CS1P-N
FROM FLO HEADER
MIN.
MIN.
4"-FLO-011013303-101CS1P-N
4"-FLO-011014307-101CS1P-N
FLO TO FLO HEADER
4"x2"
MIN.
MIN.
MIN.
4"x2"
FLO
24 5472
4"x2"
26
MIN.
25
MIN.
MIN.
26
MIN.
29
MIN.
29
MIN.
30
MIN.
30
25 24 23
22
22
21
21
20
20
19
19
18
18
17
17
16
16
15
15
14
14
13
13
12
12
11
11
10
10
9
9
8
8
7
7
6
6
5
5
4
4
3
3
2
2
1
1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JVM / STG
RDP / MAC
JAL
00
29-JAN-2010
IFD
IFD: ISSUED FOR DESIGN
MVF / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 ( EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED.
NOTES
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
COMPANY STATUS
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 FLO UTILITY DISTRIBUTION
011-074
011-076 011-075 011-080
Item Tags :
ORIGINAL SIGNED IN PROJECT FILE
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480224.pid
Discipline: PRO
SA-JER-DS011-TRJR-480224 2271-011-PID-0021-077
REV: 05
Sheet: 3 of 6
SCALE: NONE Format:
A1
41
41
40
40
39
CLD SUBHEADER
011-G-0026-B
011-G-0026-A
FLO
DS011-TRJR-480228
DS011-TRJR-480219
DS011-TRJR-480219
DS011-TRJR-480229
2656
8285
8286
7847
1-1/2"F2" 16.76
2"-FLO-011099303-101CS1P-N
5435
34
3/4"
PZV 0093
2"-FLO-011078311-101CS1P-N
16"-RES-011099003 DS011-TRJR-480138
2"-FLO-011076301-101CS1P-N
35
2"-FLO-011076302-101CS1P-N
36
2"-FLO-011078301-101CS1P-N
38 37
39
+
3"x2"
+
V NOTE 4
3"x1-1/2"
3"-LFL-011099301-101CH2F-N
0.2%
N
29
NO POCKETS
FB LO
CL300
FLUSHING OIL TO FLO HEADER DS011-TRJR-480242
38
NOTE 3
37
8288
36
3/4"
2242
35
D NOTE 4
FO LO
34
3"-FLO-011099306-101CS1P-N
MIN. 33 32
33 8"-HFO-011099003 DS011-TRJR-480138
2"-FLO-011099302-101CS1P-N
2"-FLO-011076301-101CS1P-N
DS011-TRJR-480136
31
MIN.
CLD-SUBHEADER DS011-TRJR-480229
2"-FLO-011078312-101CS1P-N
6"-SLP-011099001 DS011-TRJR-480138
6"-FLO-011099301-101CS1P-N
2522
27
MIN. 18"-CRD-011098001 DS011-TRJR-480133
30
DS011-TRJR-480229
2191
28
CLD SUBHEADER
2"-FLO-011078302-101CS1P-N
6"-FLO-011099301-101CS1P-N
31
7798
MIN.
7837
30 29
32
2"-SLP-011098019
2"-FLO-011098302-101CS1P-N
5440
29 4"-RES-011099004
4"-FLO-011099304-101CS1P-N
28
DS011-TRJR-480138
2"-FLO-011098301-101CS1P-N
7796
4920
27
6"-FLO-011077301-101CS1P-N
26
FQ
FY
TI
TT
0101
0101
0258
0258
26
2" CL300
25
25
3/4"
PI
PT
0423
0423
24
L
22
FI 0101
21
0105 L
INST.PIPING
23
1/2"
FT 0101
20
24
ZHXS
1/2" ZV 0105
ZYV 0105
+
+
TSO FC
19
S
NOTE 1 PIPING INST.
17
3/4"
16
ATM
PI 0282
21
CLOSED
OPEN
POSITIONER
BY-PASS
ZLC
ZLO
ZYC
ZHA
0105
0105
0105
0105
ZLS 0105 C
ZLS 0105 O
ZY 0105
ZHS 0105
20 19
IA
DE
18
22
ZHSR RESET 0105
ZC 0407
CL300
INST. PIPING
23
18 17 16
MIN.
3/4"-FLO-011077001-101CS1P-N MIN.
15
15
3/4" 14
MIN.
2"x3/4"
12
101CS1P 101CH2S
10
9
25 5075
8
6
11 10
9
7
12
250mm MIN.
11
MIN.
13
MIN.
13
14
3/4"
UC
8
2"-CLD-011077301-101CH2S-P UNIT 011
7
101CS1P
B.L.
B.L. 101CS1X
UNIT 691
6
IP-1320-L
5
4
4
3 2 1
3
SA-JER-IP691-TPIT-481038
6"-FLO-691217001-101CS1X-N
5
2 1
INTERCONNECTING
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
RDP / MAC
JAL
00
08-JAN-2010
IFD
IFD: ISSUED FOR DESIGN
MVF / STG
RDP / MAC
JAL
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PRECEDED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 5- PID INFORMATION OF TWIN UNIT CAN BE FOUND IN PID SA-JER-DS011-TRJR-480144.
NOTES 2 DELETED. 1- EACH BATTERY LIMIT EMERGENCY SHUTDOWN VALVE SHALL HAVE A DEDICATED SAFE-LOCATION ACTUATIING BUTTON. THE SAFE-LOCATION ACTUATING BUTTONS SHALL BE GROUPED TOGETHER AND INSTALLED AT GRADE AND LOCATED MORE THAN 15 M FROM ANY FIRE-HAZARDOUS EQUIPMENT OR PROCESS VESSEL. SAFE LOCATION BUTTONS SHALL ALSO BE AT LEAST 7.5 M BEYOND THE EDGE OF ANY FIRE-HAZARDOUS ZONE. 3- MAKE CONNECTION ON TOP OF PIPE. 4- BLOCK VALVE SHALL BE INSTALLED WITH THE STEM IN OR BELOW THE HORIZONTAL POSITION.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
COMPANY STATUS
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 FLO UTILITY DISTRIBUTION
011-076 Item Tags :
011-075 011-080
ORIGINAL SIGNED IN PROJECT FILE
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480225 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480225 2271-011-PID-0021-077
REV: 05
Sheet: 4 of 6
SCALE: NONE Format:
A1
41 40
41 14"-HFO-011027003
16"-DIE-011098001
16"-DIE-01101001
DS011-TRJR-480134
DS011-TRJR-480140
DS011-TRJR-480140
4910
4974
4973
40
39
39 DS011-TRJR-480134
DS011-TRJR-480140
4908
4975
35 34 33
38
N
2"-CLD-011098309-101CH2S-P
36
2"-CLD-011098308-101CH2S-P
2"-CLD-011098305-101CH2S-P
37
2"-CLD-011098312-101CH2S-N
8"-NAP-011021002
2"-CLD-011098304-101CH2S-P
38
14"-HFO-011098001
37 36 35 34 33
32
32
4"x2"
31
2658
31
FLO
30
30
29
29
2"-FLO-011078304-101CS1P-N 28
101CS1P 101CH2S
16"-DIE-011098008
011-G-0015-A
011-G-0015-B
011-G-0018-A
RES-011039011
011-G-0018-B
011-TV-0069
DS011-TRJR-480140
DS011-TRJR-480096
DS011-TRJR-480096
DS011-TRJR-480103
DS011-TRJR-480103
DS011-TRJR-480103
DS011-TRJR-480141
5428
2873
2872
2865
7819
2860
4977
28
27
27
26
26
20
AG 19
2"
4"
4"
4" TYP.
4"
2"-CLD-011039308-101CH2S-P
2"-CLD-011013307-101CH2S-P
2"-CLD-011039307-101CH2S-P
21
2"-CLD-011039306-101CH2S-P
22
2"-CLD-011037302-101CH2S-P
23
2"-CLD-011078328-101CH2S-N
24
2"-CLD-011037301-101CH2S-P
2"-CLD-011098322-101CH2S-P
D
25
4"-CLD-011098305-101CH2S-P
3/4"
25 24 23 22 21 20
4"
4"
UG
4" 2"
4"
4"
4"
4"
4"
AG UG
19
4"
18
DS011-TRJR-480141
DS011-TRJR-480099
4"
4"
4"
UG
2"-CLD-011200312-101CH2S-N
DS011-TRJR-480275
2869
3/4"-AWS-011033024 DS011-TRJR-480088 6969
011-SC-0021
11
4"
2"-CLD-011038301-101CH2S-P
DS011-TRJR-480099
8314
2858
AG
4"
2"-CLD-011033303-101CH2S-N
4"
4"
011-FV-0153
2"-CLD-011033304-101CH2S-N
011-FV-0051
011-D-0008 DS011-TRJR-480086
4"
3"-CLD-011033308-101CH2S-N
5039
4"
011-G-0019-B
2"-CLD-011033310-101CH2S-N
DS011-TRJR-480088
7
011-D-0008
2876
DS011-TRJR-480086
6
4" 011-D-0017
2"-CLD-011033301-101CH2S-N
DS011-TRJR-480093 4986
2906 011-G-0020-A/B
4"
2"-CLD-011033302-101CH2S-N
4"
DS011-TRJR-480087
4"
2"-CLD-011200309-101CH2S-N
DS011-TRJR-480275 8281
011-G-0020-A
3
DS011-TRJR-480087
4"
2"-CLD-011033305-101CH2S-N
4" 4"
2902
2
011-G-0020-B DS011-TRJR-480087
1
4"
2"-CLD-011033306-101CH2S-N
4"
2907 011-D-0016 DS011-TRJR-480090
4"
2"-CLD-011034302-101CH2S-N
4"
4"
7843
AG
UG
4"
4"
AG
3/4" D
DS011-TRJR-480086 2905
2"-CLD-011034303-101CH2S-N
2"-CLD-011078329-101CH2S-N
2" AG
2" UG
0.2%
101CS1P 101CH2S
4"
6800
3/4" D
10
011-HV-0038
DS011-TRJR-480096
DS011-TRJR-480080
4988
5031
8
DS011-TRJR-480081
011-G-0017-A
011-G-0017-B
011-HV-0020
DS011-TRJR-480101
DS011-TRJR-480101
DS011-TRJR-480066
2867
2866
7676
4"-CLD-011030304-101CH2S-P
2913
011-C-0003
6 5
011-C-0003
2"-CLD-011030302-101CH2S-P DS011-TRJR-480081
7
DS011-TRJR-480080
2"-CLD-011030307-101CH2S-P
2919
4
5035
3 011-S-0002
011-S-0002
DS011-TRJR-480102
DS011-TRJR-480102
2911
2909
011-C-0003
2"-CLD-011030301-101CH2S-P 011-C-0003 DS011-TRJR-480081
2
DS011-TRJR-480080
2"-CLD-011030303-101CH2S-P
2920
1
2918 011-D-0009 DS011-TRJR-480089
4"
011-D-0017
2"-CLD-011036301-101CH2S-N
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
UG
4"
2"-CLD-011035301-101CH2S-P
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
DS011-TRJR-480091
03
6408
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
011-D-0030
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
DS011-TRJR-480264
00
29-JAN-2010
IFD
IFD: ISSUED FOR DESIGN
JGT / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
011-K-0001
2908
AG 2"-CLD-011035302-101CH2S-N
6771
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- DELETED. 2- FUTURE CONNECTION. 3- DELETED.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
011-C-0003
DS011-TRJR-480093
MIN
2214
11
4"
AG
011-D-0008
12
9
011-FV-0096
UG
DS011-TRJR-480090
2"-FLO-011078305-101CS1P-N
AG
13
2"-FLO-011078309-101CS1P-N
FLO
FLO
UG
14
2903
2912
011-D-0016
UG
15
4" 4"
4"
4"
101CH2S 101CS1P
2"-CLD-011036302-101CH2S-N
5037 011-SC-0026
6"-CLD-011078302-101CH2S-N
5 4
4"
2"-CLD-011078336-101CH2S-P
2874
4"
2"-CLD-011039305-101CH2S-P
MIN.
4"
2"-CLD-011039304-101CH2S-P
4"
2"-CLD-011034301-101CH2S-N
2"-CLD-011033309-101CH2S-N
DS011-TRJR-480088
8
4"
6"-CLD-011078301-101CH2S-N
2"-CLD-011033307-101CH2S-N
011-G-0019-A
4"
4"
5000
2904
9
4"
2"-CLD-011039303-101CH2S-P
DS011-TRJR-480102
4"
AG
DS011-TRJR-480087
DS011-TRJR-480087
8282
4"
011-FV-0152
2"-CLD-011200308-101CH2S-N
4"
UG
5038
4"
DS011-TRJR-480275
10
4"
2"-CLD-011013309-101CH2S-P
DS011-TRJR-480141
4"
2"-CLD-011033312-101CH2S-N
4"
4" 011-S-0001 2859
011-G-0016-A 011-SC-0045
011-S-0001
2"-CLD-011013310-101CH2S-P
DS011-TRJR-480141
2868
14
4"
2"-CLD-011027309-101CH2S-P
2"-CLD-011038302-101CH2S-P
16
2"-CLD-011039302-101CH2S-P
011-G-0016-B
6"x4"
4"
4"
011-FV-0012
4"
UG
2"-CLD-011030305-101CH2S-N
4"
4996
15
2"-CLD-011013308-101CH2S-P
2"-CLD-011037303-101CH2S-P
2"-CLD-011038303-101CH2S-P
DS011-TRJR-480099
AG
4976
UG
2"-CLD-011039301-101CH2S-P
AG
011-FV-0155
16
12
CLD TO HEADER5476 17
MIN
17
13
18
0.2%
6"-CLD-011078301-101CH2S-N
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080 011-077
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CLOSED DRAIN UTILITY DISTRIBUTION ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480226 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480226 2271-011-PID-0021-078
REV: 05
Sheet: 1 of 8
SCALE: NONE Format:
A1
41
41
40
40
N
39
39
38
38
37
37
36
36
35
35
011-FV-0018 DS011-TRJR-480043
34
34
5040
33 32
33 011-FV-0019
011-FV-0023
011-FV-0024
011-G-0014A/B
011-D-0004
011-G-0014-A
011-G-0014-B
011-G-0012-A
011-G-0012-B
011-A-0001
011-G-0010-A
011-G-0010-B
011-G-0008-A
011-G-0008-B
011-TV-0057
DS011-TRJR-480043
DS011-TRJR-480043
DS011-TRJR-480044
DS011-TRJR-480066
DS011-TRJR-480046
DS011-TRJR-480066
DS011-TRJR-480066
DS011-TRJR-480065
DS011-TRJR-480065
DS011-TRJR-480045
DS011-TRJR-480064
DS011-TRJR-480064
DS011-TRJR-480063
DS011-TRJR-480063
DS011-TRJR-480027
5042
5041
5043
6214
5049
3062
3063
3064
3065
3074
3069
3071
3073
3075
4956
32
4"
2"-CLD-011026303-101CH2S-P
2"-CLD-011026304-101CH2S-P
2"-CLD-011026301-101CH2S-P
2"-CLD-011026302-101CH2S-P
2"-CLD-011014311-101CH2S-P
4"
4"
4"
4"
4"
29 28 27 26 25
4"
4"
4"
24
4"
4"
4"
4"
4"
30
UG
UG
23
4"
23
4"
4"
4"
4"
4"
UG
24
AG
2"-CLD-011019306-101CH2S-P
AG
4"
2"-CLD-011027304-101CH2S-P
2"-CLD-011027303-101CH2S-P
2"-CLD-011019308-101CH2S-N
4"-CLD-011027306-101CH2S-P
4"
4"
4"
2"-CLD-011027302-101CH2S-P
4"
4"
AG
2"-CLD-011027301-101CH2S-P
25
2"-CLD-011018309-101CH2S-P
26
4"
27
2"-CLD-011018308-101CH2S-P
28
4"
29
2"-CLD-011018301-101CH2S-P
30
31
2"-CLD-011018306-101CH2S-P
31
0.2 %
22
CLD 6"-CLD-011078301-101CH2S-N 5476 FROM HEADER PID-480226 21
6"-CLD-011078301-101CH2S-N
22 CLD 5477 TO HEADER PID-480228 21
20 19
20 011-C-0002
19
2"-CLD-011018303-101CH2S-P
DS011-TRJR-480044
18
5046
18
2"-CLD-011200305-101CH2S-P AG
011-LDV-0026
DS011-TRJR-480275
DS011-TRJR-480004
DS011-TRJR-480004
DS011-TRJR-480004
DS011-TRJR-480046
8263
3038
3043
3044
6980
011-FV-0052 DS011-TRJR-480051
DS011-TRJR-480043
DS011-TRJR-480057 3032
3020
4"
4"
2"-CLD-011024303-101CH2S-P
DS011-TRJR-480057
DS011-TRJR-480044
3031
5048
4"
2"-CLD-011023301-101CH2S-P
4"
DS011-TRJR-480054
2"-CLD-011024304-101CH2S-P
3056
3048
4"
4"
2"-CLD-011200326-101CH2S-N
DS011-TRJR-480273
5053
7887
4" 011-E-0022
011-G-0007-A
2"-CLD-011021302-101CH2S-N
3066
DS011-TRJR-480052
DS011-TRJR-480052 5055 011-FV-0125
2"-CLD-011022304-101CH2S-P
2"
2"-CLD-011021303-101CH2S-N
4"
DS011-TRJR-480052 5054 011-G-0007-B DS011-TRJR-480051 3067
2"-FLO-011078306-101CS1P-N AG UG 3/4"
D 2"-CLD-011078330-101CH2S-N
MIN.
2657
2"
101CS1P 101CH2S
FLO
NOTE 1
3076
10 12"-CRU-011001007
2"-CLD-011002307-101CH2S-N
011-LV-0080
2"-CLD-011044304-101CH2S-N
4"
DS011-TRJR-480004
2"-CLD-011002308-101CH2S-N
9
DS011-TRJR-480114
7712
6773
12"-CRU-011001007
8
DS011-TRJR-480004 7711
7 6 5 4
0,2%
3
UG
101CH2S 101CS1P
FLO 7829
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
011-FV-0025
011-G-0005-A
011-G-0005-B
011-D-0005
011-D-0004
011-SC-0004
011-SC-0029
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
DS011-TRJR-480055
DS011-TRJR-480055
DS011-TRJR-480047
DS011-TRJR-480047
DS011-TRJR-480047
DS011-TRJR-480050
DS011-TRJR-480046
DS011-TRJR-480275
DS011-TRJR-480275
00
29-JAN-2010
IFD
IFD: ISSUED FOR DESIGN
ARV / STG
RDP / MAC
JAL
3054
3053
5050
3068
3070
3051
3049
8264
8265
REV
2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 2- DELETED.
05
011-G-0011-B
1- EACH INSTRUMENT TAG NUMBER IS PRECEDED BY 011 (EX. 011-TT-0001).
1- DELETED.
1
AG
011-G-0011-A
GENERAL NOTES
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
11
DS011-TRJR-480114
2
4"
2"-CLD-011022306-101CH2S-P
011-G-0006-A
2"-CLD-011044302-101CH2S-N
4"
4"
2"-CLD-011023303-101CH2S-P
6"-CLD-011078321-101CH2S-N
3058
1
12
6"-CLD-011078301-101CH2S-N
DS011-TRJR-480052 011-PDV-0046
3077
MIN.
4"
4"-CLD-011022303-101CH2S-P
2"-CLD-011078337-101CH2S-N
3055
011-E-0022
13
DS011-TRJR-480051
4"
2"-CLD-011022302-101CH2S-P
011-G-0006-B
2"-CLD-011044303-101CH2S-N
DS011-TRJR-480114
2"-CLD-011200303-101CH2S-N
2"-CLD-011022305-101CH2S-P
011-SC-0043
DS011-TRJR-480052
2"-CLD-011022301-101CH2S-P
3052
2
3059
DS011-TRJR-480052
4 3
4"
14
AG
4"
4"-CLD-011019301-101CH2S-P
011-C-0004
UG
4"
011-LV-0034
4"
DS011-TRJR-480053
2"-CLD-011024301-101CH2S-P
6 5
011-G-0009-B
2"-CLD-011022308-101CH2S-P
DS011-TRJR-480056 3019
6958
4"-CLD-011021301-101CH2S-N
011-C-0006
7
4"
3"-CLD-011002304-101CH2S-P
4"
2"-CLD-011023302-101CH2S-P
DS011-TRJR-480054
8
DS011-TRJR-480050
5318
3"x2"
5057 011-C-0005
DS011-TRJR-480004
3036
4"
DS011-TRJR-480056
9
DS011-TRJR-480053
5056
011-C-0006
2"-FLO-011078310-101CS1P-N
10
011-G-0009-A
2"-CLD-011022307-101CH2S-P
DS011-TRJR-480004
4834
2"-CLD-011019303-101CH2S-P
011-LV-0038
11
DS011-TRJR-480004
2"-CLD-011200310-101CH2S-N
2"-CLD-011018307-101CH2S-P
011-G-0013-B
011-LDV-0032
4"
011-C-0002
12
2"-CLD-011024302-101CH2S-P
011-HV-0003
2"-CLD-011019302-101CH2S-P
DS011-TRJR-480044
13
4"
4"
2"-CLD-011018312-101CH2S-P
011-G-0013-A
011-E-0003-C/D
4"
011-LG-0019
5052
15
011-HV-0001
2"-CLD-011019304-101CH2S-P
6859
AG
14
16
2"-CLD-011021305-101CH2S-N
2"-CLD-011021304-101CH2S-N
2"-CLD-011019309-101CH2S-P
4"
4"
011-E-0003-A/B
2"-CLD-011002306-101CH2S-N
2"-CLD-011018315-101CH2S-P
011-E-0003-A/B
2"-CLD-011002302-101CH2S-P
AG UG 011-LG-0011
011-E-0003-C/D
2"-CLD-011002303-101CH2S-P
3050
17
011-SC-0007
UG
15
UG
4"
16
4"
2"-CLD-011002301-101CH2S-P
DS011-TRJR-480044
2"-CLD-011002305-101CH2S-N
2"-CLD-011018304-101CH2S-P
2"-CLD-011002304-101CH2S-P
011-C-0002
2"-CLD-011023304-101CH2S-P
17
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080 011-077
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CLOSED DRAIN UTILITY DISTRIBUTION ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480227.pid
Discipline: PRO
SA-JER-DS011-TRJR-480227 2271-011-PID-0021-078
REV:
05
Sheet: 2 of 8
SCALE: NONE Format:
A1
41
41
40
40
39
39
N
38 37
38 37
35
35
34
34
33
33
32
32
31
31
30
30
29
29
28
28
27
6"-CLD-011078301-101CH2S-N
6"-CLD-011078301-101CH2S-N
CLD
CLD
0.2 %
26 5477FROM HEADER
DS011-TRJR-480227 0.2%
25 24
4"
TO CLD HEADER
36
DS011-TRJR-480231 5481
36
27 26 25
011-D-0001
4"-CLD-011006302-101CH2S-P
24
DS011-TRJR-480011 2826
23
23 011-SC-0017
2"-CLD-011200315-101CH2S-N
4"
22
22
DS011-TRJR-480274 8287
21
21 011-D-0001
2"-CLD-011006306-101CH2S-P
4"
DS011-TRJR-480011
20
20
2827
2"-CLD-011006308-101CH2S-P
19
19
DS011-TRJR-480011
4"
18
011-PDV-0006
2"-CLD-011007301-101CH2S-P
6371
18
DS011-TRJR-480013 4904
17
17 011-PDV-0005
2"-CLD-011006301-101CH2S-P 16
16
DS011-TRJR-480010 4901
15
15
UG
AG
14
011-G-0002-A
6062
4"
2"-CLD-011008303-101CH2S-P
13
4"
DS011-TRJR-480015
12 011-G-0002-B
4"
2"-CLD-011008304-101CH2S-P
12
011-A-0005-A/D
2"-CLD-011037308-101CH2S-P
2805
11
DS011-TRJR-480008
UG
AG
13
14
011-PDV-0449
2"-CLD-011004311-101CH2S-P
DS011-TRJR-480097
4"
11
2815
DS011-TRJR-480015 2812
011-SC-0049
2"-CLD-011200321-101CH2S-P
10
10
DS011-TRJR-480274 011-G-0001-B
9
2"-CLD-011001308-101CH2S-N
4"
2"-CLD-011001309-101CH2S-N
4"
4"
9393
9
DS011-TRJR-480002 2830
8 7
011-G-0001-A
4"
DS011-TRJR-480002
8
AG
UG
2831
4"
7
011-FV-0118
2"-CLD-011025302-101CH2S-P
6"-CLD-011078316-101CH2S-N
DS011-TRJR-480058
6 5 4 3
2"-CLD-011200306-101CH2S-N
5060
6
011-SC-0019
5
DS011-TRJR-480274
4
8289
4"
011-FV-0029
2"-CLD-011025301-101CH2S-N
3
DS011-TRJR-480058 5058
2
2
4"
1
4"
FROM 011-G-0026-A
2"-CLD-011076302-101CS2P-P
DS011-TRJR-480219
1
5323
4" 2"-CLD-011078327-101CH2S-N
DS011-TRJR-480219
UG
5322
2"-FLO-011078301-101CS1P-N 3/4" D
MIN.
2656
FROM 011-G-0026-B
2"-CLD-011076303-101CS2P-P
05
13-MAR-2013
AB
04
30-SEP-2011
DS011-TRJR-480219
03
5325
MIN. 101CS1P 101CH2S
FLO
AG
4"
2"-CLD-011076301-101CH2S-P
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
00
29-JAN-201
IFD
IFD: ISSUED FOR DESIGN
ARV / STG
RDP / MAC
JAL
3/4"-SLP-011076009
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480019.
NOTES 1- DELETED. 2- DELETED.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080 011-077
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CLOSED DRAIN UTILITY DISTRIBUTION ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480228.pid
Discipline: PRO
SA-JER-DS011-TRJR-480228 2271-011-PID-0021-078
REV: 05
Sheet: 3 of 7
SCALE: NONE Format:
A1
41
41
40
40
39
39
N
38 37 36
37
011-E-0008
011-E-0009-A
011-E-0009-B
011-E-0001
011-E-0002
011-PV-0007
011-E-0029
011-E-0034
011-E-0037
DS011-TRJR-480009
DS011-TRJR-480010
DS011-TRJR-480010
DS011-TRJR-480003
DS011-TRJR-480003
DS011-TRJR-480002
DS011-TRJR-480098
DS011-TRJR-480060
DS011-TRJR-480136
2600
2595
2597
4820
2547
2549
5433
5305
2599
38
36 011-AS-0001
011-E-0037
DS011-TRJR-480008
DS011-TRJR-480009
DS011-TRJR-480010
DS011-TRJR-480010
DS011-TRJR-480003
DS011-TRJR-480003
DS011-TRJR-480058
DS011-TRJR-480062
DS011-TRJR-480109
DS011-TRJR-480136
2601
5308
7750
7752
2529
2528
5059
2548
2828
2550
AG UG
2"-CLD-011098320-101CH2S-P
2"-CLD-011042301-101CH2S-P AG UG
AG UG
4"
AG UG
4"
UG
4"
4"
AG
AG UG
4"
2"-CLD-011025313-101CH2S-P AG UG
4"
AG UG
4"
AG UG
4"
AG UG
2"-CLD-011001312-101CH2S-P
2"-CLD-011001301-101CH2S-P
2"-CLD-011001310-101CH2S-P AG UG
4"
AG UG
4"
AG UG
2"-CLD-011005311-101CH2S-P
2"-CLD-011005312-101CH2S-P AG UG
4"
AG UG
4"
AG UG
6897
0.2%
011-E-0009-B
011-E-0009-A
011-A-0001
DS011-TRJR-480010
DS011-TRJR-480010
DS011-TRJR-480061
7751
2527
2825
UG AG
UG AG
4"
UG AG
4"
UG AG
4"
UG AG
4"
4"
UG AG
FLO
2"-FLO-011078302-101CS1P-N
2522
2"-CLD-011078341-101CH2S-N AG UG
26
UG AG
25
23
2"-CLD-011098315-101CH2S-P
2"-CLD-011077301-101CH2S-P
2"-CLD-011098310-101CH2S-P
2"-CLD-011098311-101CH2S-P
2"-CLD-011098326-101CH2S-P
6960
2"-CLD-011098316-101CH2S-P
2"-CLD-011098313-101CH2S-P
6911
DS011-TRJR-480132
4" 4"
7749
HFO-011098014
DS011-TRJR-480108
6"-CLD-011078317-101CH2S-N
DS011-TRJR-480010
2526
011-A-0006-A/B
2"-CLD-011042303-101CH2S-N
4"
6978
3/4"
DS011-TRJR-480010
2"-CLD-011098325-101CH2S-P
DS011-TRJR-480136
D
011-E-0009-A
2"-CLD-011025316-101CH2S-P
2"-CLD-011005309-101CH2S-P
2"-CLD-011005301-101CH2S-P
011-E-0009-B
4"
4"
27
AG UG SLP-011098003
101CH2S
17
15
29
24
101CS1P
18
16
30
FUTURE
0.2%
UG AG
0.2%
UG AG
4"-CLD-011025304-101CH2S-N
4"
4"
4"
UG AG
2"-CLD-011005302-101CH2S-P
2"-CLD-011005310-101CH2S-P
19
31
6"-CLD-011078317-101CH2S-N
23
20
32
28
24
21
33
4"-CLD-011098301-101CH2S-N
25
22
34
AG UG
2"-CLD-011098324-101CH2S-P
26
TO HEADER
27
CLD
28
AG UG
DS011-TRJR-480216 7841
4"
29
2"-CLD-011005305-101CH2S-P
30
4"
31
2"-CLD-011005308-101CH2S-P
32
4"
33
4"
2"-CLD-011004306-101CH2S-P
34
35
DS011-TRJR-480289
2"-CLD-011230301-101CH2S-N
011-E-0033
2"-CLD-011098323-101CH2S-P
011-E-0035
2"-CLD-011025315-101CH2S-P
011-E-0023
2"-CLD-011025305-101CH2S-P
011-E-0002
2"-CLD-011037309-101CH2S-P
011-E-0001
2"-CLD-011001304-101CH2S-N
011-E-0009-B
2"-CLD-011001313-101CH2S-P
011-E-0009A
2"-CLD-011005306-101CH2S-P
011-E-0008
2"-CLD-011005307-101CH2S-P
011-E-0007
35
6"-SLP-011098002
8"-KER-011025002
6"-FLO-011077301
DS011-TRJR-480134
DS011-TRJR-480133
DS011-TRJR-480225
4905
4917
5075
22 21 20 19 18
3"-NAP-011098001
8"-AWS-011044002
8"-KER-011025001
16"-SLP-011098001
DS011-TRJR-480135
DS011-TRJR-480132
DS011-TRJR-480135
DS011-TRJR-480136
4928
4874
4926
4934
17 16
AG UG
15
14
14
MIN.
6"-CLD-011078317-101CH2S-N
011-SC-0051
4
011-FV-0175
011-FV-0120
011-FV-0030
011-SC-0003
DS011-TRJR-480275
DS011-TRJR-480001
DS011-TRJR-480062
DS011-TRJR-480274
DS011-TRJR-480060
8300
4798
5066
7848
5063
FLO 7847
FLO 7837
4"
UG AG
UG AG
UG AG
10
2"-CLD-011098314-101CH2S-P
2"-CLD-011099301-101CH2S-P
2"-CLD-011099302-101CH2S-P
UG AG
4"
4"
4"
UG AG
2"-CLD-011098319-101CH2S-P
UG AG
4"
UG AG
2"-CLD-011098302-101CH2S-P
UG AG
4"
4"
4"
UG AG
2"-CLD-011098317-101CH2S-P
101CH2S 101CS1P
4"
4" 3/4" D
UG AG
2"-CLD-011098306-101CH2S-P
101CH2S 101CS1P
11
2"-CLD-011098307-101CH2S-P
3/4" D
UG AG
2"-CLD-011099304-101CH2S-P
2"-CLD-011025304-101CH2S-P
2"-CLD-011025303-101CH2S-P
2"-CLD-011200307-101CH2S-P
2"-CLD-011200302-101CH2S-P
2"-CLD-011200301-101CH2S-P
2"-CLD-011025306-101CH2S-P
2"-CLD-011002309-101CH2S-P
5
2"-CLD-011001307-101CH2S-N
6
2"-CLD-011037004-101CH2S-P
7
2"-CLD-011001303-101CH2S-P
8
2"-CLD-011200329-101CH2S-N
10
UG AG
2"-CLD-011099303-101CH2S-P
UG AG
2"-CLD-011078339-101CH2S-N
UG AG
13 12
2"-FLO-011078312-101CS1P-N
UG AG
4"
4"
UG AG
4"
UG AG
UG AG
2"-CLD-011078338-101CH2S-N
AG
4"
UG AG
4"
4"
UG AG
4"
UG AG
4"
4"
UG AG
UG
2"-FLO-011078311-101CS1P-N
11
4"
4"
12
9
MIN.
4"-CLD-011025304-101CH2S-N
13
9 8 7 6 5
8"-HFO-011037006
6"-DIE-011025003
8"-HFO-011025003
10"-HFO-011010003
18"-CRU-011098001
DS011-TRJR-480138
DS011-TRJR-480133
DS011-TRJR-480132
DS011-TRJR-480137
DS011-TRJR-480133
4943
4916
4884
4938
4918
4
3 2
3 011-FV-0002
011-FV-0144
SLP-011098019
011-SC-0002
011-SC-0020
011-FV-0119
12"-HFO-011038004
6"-DIE-011025002
6"-DIE-011037007
10"-HFO-011098006
16"-HFO-011040006
DS011-TRJR-480002
DS011-TRJR-480098
DS011-TRJR-480002
DS011-TRJR-480274
DS011-TRJR-480274
DS011-TRJR-480060
DS011-TRJR-480137
DS011-TRJR-480133
DS011-TRJR-480132
DS011-TRJR-480132
DS011-TRJR-480138
4802
4991
7713
7851
7850
5064
4939
4915
4887
4879
4941
2
1
1
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY ( EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- DELETED. 2- DELETED.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
00
29-JAN-2010
IFD
IFD: ISSUED FOR DESIGN
ARV / STG
RDP / MAC
JAL
REV
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 011-075 011-080 011-077
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CLOSED DRAIN UTILITY DISTRIBUTION ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480229 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480229 2271-011-PID-0021-078
REV: 05
Sheet: 4 of 7
SCALE: NONE Format:
A1
41
41
40
40 011-F-0002
011-F-0002
011-F-0002
011-F-0002
011-F-0001
011-F-0001
011-F-0001
011-F-0001
011-E-0004-B
011-E-0004-A/B
011-E-0004-B
011-E-0004-A
011-E-0004-A/B
011-E-0004-A
10"-CRU-011010006
10"-CRU-011003001
011-D-0003
DS011-TRJR-480073
DS011-TRJR-480072
DS011-TRJR-480078
DS011-TRJR-480075
DS011-TRJR-480037
DS011-TRJR-480034
DS011-TRJR-480040
DS011-TRJR-480039
DS011-TRJR-480005
DS011-TRJR-480005
DS011-TRJR-480005
DS011-TRJR-480005
DS011-TRJR-480005
DS011-TRJR-480005
DS011-TRJR-480019
DS011-TRJR-480005
DS011-TRJR-480023
7767
7705
6322
7790
7689
7700
7697
7692
2692
7690
2691
2689
7693
2690
4930
4843
6892
7695
7691
AG UG 4"
31
4"
4"
4"
4"
4"
4"
0.2%
18 17
4"
4"
11 10 9
2"-CLD-011017306-101CH2S-P
2"-CLD-011017307-101CH2S-P
3"x2"
31
6"-CLD-011078322-101CH2S-N
4"
4"
4"
4"
4"
4"
4"
UG
CLD TO HEADER PID-480231
29 5502
28
4"
4"
4"
4"
4"
4"
4"
4"
4"
4"
4"
4"
4"
4"
4"
4"
4"
4"
4"
4"
4"
4"
4"
2"-CLD-011014309-101CH2S-P
2"-CLD-011014310-101CH2S-P
2"-CLD-011015306-101CH2S-P
2"-CLD-011015305-101CH2S-P
2"-CLD-011015302-101CH2S-P
2"-CLD-011015301-101CH2S-P
2"-CLD-011015308-101CH2S-P
2"-CLD-011015307-101CH2S-P
2"-CLD-011015304-101CH2S-P
2"-CLD-011015303-101CH2S-P
2"-CLD-011015314-101CH2S-P
2"-CLD-011015313-101CH2S-P
2"-CLD-011015310-101CH2S-P
2"-CLD-011015309-101CH2S-P
22 21 20 19 18
011-FV-0015-F
011-FV-0015-H
011-FV-0032
011-E-0020-F
011-E-0020-D/E
011-E-0020-C
011-E-0020-A/B
011-E-0019-F
011-E-0019-D/E
011-E-0019-C
011-E-0019-A/B
011-E-0018-C/D
DS011-TRJR-480032
DS011-TRJR-480033
DS011-TRJR-480066
DS011-TRJR-480029
DS011-TRJR-480029
DS011-TRJR-480029
DS011-TRJR-480029
DS011-TRJR-480028
DS011-TRJR-480028
DS011-TRJR-480028
DS011-TRJR-480028
DS011-TRJR-480027
4970
4972
5067
2745
2742
2740
2739
2733
2735
2738
2732
2760
17
4"
4"
UG AG
2"-CLD-011016304-101CH2S-P
2"-CLD-011016302-101CH2S-P
2"-CLD-011028307-101CH2S-P
2"-CLD-011028305-101CH2S-P
2"-CLD-011028303-101CH2S-P
23
AG UG
4"
FLO
2"-CLD-011016305-101CH2S-P
2"-CLD-011016303-101CH2S-P
4"-CLD-011016301-101CH2S-N
2"-CLD-011028308-101CH2S-P 4"
2"-CLD-011015316-101CH2S-P
2"-CLD-011028306-101CH2S-P 4"
4"
4"
24
2"-CLD-011015315-101CH2S-P
4967
2"-CLD-011015311-101CH2S-P
DS011-TRJR-480031
4964
2"-CLD-011015312-101CH2S-P
DS011-TRJR-480030
5024
2"-CLD-011018310-101CH2S-P
DS011-TRJR-480070
5022
2"-CLD-011027305-101CH2S-P
DS011-TRJR-480069
5071
2"-CLD-011016307-101CH2S-P
DS011-TRJR-480068
5069
25
2"-CLD-011016308-101CH2S-P
DS011-TRJR-480067
26
UG AG
2"-CLD-011016306-101CH2S-P
011-FV-0015-C
2"-CLD-011016301-101CH2S-P
011-FV-0015-A
4"-CLD-011028306-101CH2S-N
011-FV-0034-H
2"-CLD-011028304-101CH2S-P
101CH2S 101CS1P
011-FV-0034-F
2"-CLD-011098321-101CH2S-P
12
AG UG
30
011-FV-0034-D
2"-CLD-011028301-101CH2S-P
13
4" UG
4"
4"
4"
011-FV-0034-B
7871
14
4"
4"
16 15
2"-CLD-011017308-101CH2S-P
2"-CLD-011017301-101CH2S-P
2"-CLD-011017304-101CH2S-P 4"UG
0.2%
0.2% D
2"-FLO-011078317-101CS1P-N
19
32
27
4"-CLD-011028302-101CH2S-N
3/4"
22
20
3"-CLD-011003301-101CH2S-P
AG
23
21
34
UG AG
2"-CLD-011028302-101CH2S-P
24
2"-CLD-011078342-101CH2S-P
25
35
33
0.2%
29
26
36
0.2%
6"-CLD-011078322-101CH2S-N
38 37
6"x4"
30
27
N
AG
AG
6"x4"
28
2"-CLD-011017303-101CH2S-P
32
2"-CLD-011029306-101CH2S-P
33
2"-CLD-011029307-101CH2S-P
34
4"
35
39
2"-CLD-011012307-101CH2S-P
7687
2"-CLD-011003305-101CH2S-P
7688
2"-CLD-011010303-101CH2S-P
7792
2"-CLD-011003302-101CH2S-P
7766
2"-CLD-011003313-101CH2S-P
7696
2"-CLD-011003301-101CH2S-P
7785
2"-CLD-011003303-101CH2S-P
0111-F-0001 DS011-TRJR-480038
2"-CLD-011017305-101CH2S-P
011-F-0001 DS011-TRJR-480041
2"-CLD-011017302-101CH2S-P
011-F-0001 DS011-TRJR-480035
2"-CLD-011029305-101CH2S-P
011-F-0001 DS011-TRJR-480036
2"-CLD-011029308-101CH2S-P
011-F-0002 DS011-TRJR-480076
2"-CLD-011029302-101CH2S-P
011-F-0002 DS011-TRJR-480077
2"-CLD-011029301-101CH2S-P
011-F-0002 DS011-TRJR-480071
2"-CLD-011029304-101CH2S-P
36
011-F-0002 DS011-TRJR-480074
2"-CLD-011029303-101CH2S-P
37
2"-CLD-011003304-101CH2S-P
38
2"-CLD-011003314-101CH2S-P
39
011-FV-0034-A
011-FV-0034-C
011-FV-0034-E
011-FV-0034-G
011-FV-0015-B
011-FV-0015-D
DS011-TRJR-480067
DS011-TRJR-480068
DS011-TRJR-480069
DS011-TRJR-480070
DS011-TRJR-480030
DS011-TRJR-480031
5068
5070
5021
5023
4963
4968
011-FV-0015-E
011-FV-00015-G
011-FV-0022
011-E-0020-F
011-E-0020-D/E
011-E-0020-C
011-E-0020-A/B
011-E-0019-F
011-E-0019-D/E
011-E-0019-C
011-E-0019-A/B
011-E-0018-C/D
DS011-TRJR-480032
DS011-TRJR-480033
DS011-TRJR-480044
DS011-TRJR-480029
DS011-TRJR-480029
DS011-TRJR-480029
DS011-TRJR-480029
DS011-TRJR-480028
DS011-TRJR-480028
DS011-TRJR-480028
DS011-TRJR-480028
DS011-TRJR-480027
4969
4971
5044
2744
2746
2741
2743
2734
2736
2731
2737
2759
16 15 14 13 12 11 10 9
14"-HFO-011090011 DS011-TRJR-480134
8
8
5427
7
7
6
6
5
5
4
4
3
3
2
2
1
1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
00
29-JAN-2010
IFD
IFD: ISSUED FOR DESIGN
ARV / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
APPR/AUTH BY
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY ( EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- DELETED. 2- DELETED.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
COMPANY STATUS
REVISION MEMO
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 011-075 011-080 011-077
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CLOSED DRAIN UTILITY DISTRIBUTION ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480230.pid
Discipline: PRO
SA-JER-DS011-TRJR-480230 2271-011-PID-0021-078
REV:
05
Sheet: 5 of 7
SCALE: NONE Format:
A1
41
41
101CS1P 101CH2S
2211
39
2"
38
3/4"
40
D
011-G-0004 B
DS011-TRJR-480019
DS011-TRJR-480021
4931
2665
011-C-0001
6"-CLD-011078308-101CH2S-N
37 36
6"
6"-CLD-011011301-101CH2S-P
DS011-TRJR-480020 4936
35
011-FV-0009
2"-CLD-011012301-101CH2S-P
4"
DS011-TRJR-480022
34
4940 011-G-0004 A
2"-CLD-011011302-101CH2S-P
4"
DS011-TRJR-480021
33
2668 011-E-0017-B
011-E-0016-B
011-E-0017-B
011-E-0016-B
011-E-0018 A/B
011-E-0018 A/B
011-E-0017 A
011-E-0017 A
011-E-0016 A
011-E-0016 A
011-E-0015 A/B
011-FV-0008
DS011-TRJR-480026
DS011-TRJR-480025
DS011-TRJR-480026
DS011-TRJR-480025
DS011-TRJR-480027
DS011-TRJR-480027
DS011-TRJR-480026
DS011-TRJR-480026
DS011-TRJR-480025
DS011-TRJR-480025
DS011-TRJR-480024
DS011-TRJR-480021
2685
2684
2686
2694
2682
2683
2680
2681
2673
2674
6358
4937
2"-CLD-011011304-101CH2S-P
31
011-D-0003
2"-CLD-011013313-101CH2S-P
TO HEADER
35
DS011-TRJR-480216 5478
34 33
31
UG 30
CRD-011003015
4"
2"-CLD-011003316-101CH2S-P
DS011-TRJR-480005
AG 011-G-0003
2"-CLD-011012306-101CH2S-N
4"
UG
AG
10776
UG
29
DS011-TRJR-480022 4942
28
011-G-0003 A
2"-CLD-011012302-101CH2S-P
4"
DS011-TRJR-480022
27
2666 011-G-0003 B
2"-CLD-011012303-101CH2S-P
4"
DS011-TRJR-480022
26
2667 011-E-0010
2"-CLD-011008308-101CH2S-P
4"
4"
4"
4"
4"
4"
4"
36
CLD
4"
0.2 %
2"-CLD-011013303-101CH2S-P
2"-CLD-011013304-101CH2S-P
2"-CLD-011014301-101CH2S-P
2"-CLD-011014303-101CH2S-P
2"-CLD-011014307-101CH2S-P
2"-CLD-011014308-101CH2S-P 4"
37
4"
UG
4"
25
38
32
AG
4"
26
4"
27
2"-CLD-011013305-101CH2S-P
6"-CLD-011078322-101CH2S-N
28
2"-CLD-011014302-101CH2S-P
CLD 5502FROM HEADER PID-48230
2"-CLD-011013306-101CH2S-P
2"-CLD-011014304-101CH2S-P
29
2687
39
UG
4"
2"-CLD-011012304-101CH2S-P AG
DS011-TRJR-480023
30
AG
4"
32
N
011-HV-0008
2"-CLD-011011303-101CH2S-P
2"-FLO-011078308-101CS1P-N
FLO
2"-CLD-011010302-101CH2S-P
40
MIN.
2"-CLD-011078324-101CH2S-P
25
DS011-TRJR-480016 6066
24
011-E-0015 A/B
2"-CLD-011013314-101CH2S-P
4"
24
DS011-TRJR-480024 7831
23
DS011-TRJR-480024
0.2%
22
23
011-E-0015 A/B
2"-CLD-011013312-101CH2S-P
4"
22
6357 011-FV-0052
2"-CLD-011040302-101CH2S-P
4"
DS011-TRJR-480104
21
21
5001
4"
20
011-FT-0052
2"-CLD-011040313-101CH2S-P
20
DS011-TRJR-480104 7834
19
2"-CLD-011200325-101CH2S-N
4"
19
011-SC-0023 DS011-TRJR-480273 7886
18
4"
4"
4"
4"
4"
4"
3/4"-HFO-011014114
4"
4"
4"
4"
4"
4"
4"
4"
4"
4"
4"
4"
4" FLO 7832
2"-CLD-011027310-101CH2S-P
7 6 5 4 3 2
4"
9416
15
011-FV-0013
14
4955
2"-CLD-011014306-101CH2S-P
4"
4945
2"-CLD-011013317-101CH2S-P
2"-CLD-011013316-101CH2S-P
2"-CLD-011020301-101CH2S-P
2"-CLD-011014317-101CH2S-P
2"-CLD-011014314-101CH2S-P
2"-CLD-011014316-101CH2S-P
2"-CLD-011013318-101CH2S-P
2"-CLD-011013319-101CH2S-P
2"-CLD-011014315-101CH2S-P
2"-CLD-011014318-101CH2S-P
2"-CLD-011014319-101CH2S-P
2"-CLD-011015319-101CH2S-P
2"-CLD-011015317-101CH2S-P
2"-CLD-011015322-101CH2S-P
2"-CLD-011015318-101CH2S-P
2"-CLD-011015321-101CH2S-P
2"-CLD-011015320-101CH2S-P
2"-CLD-011015323-101CH2S-P
2"-CLD-011015325-101CH2S-P
2"-CLD-011015326-101CH2S-P
2"-CLD-011015324-101CH2S-P
2"-CLD-011015328-101CH2S-P
2"-CLD-011013302-101CH2S-P
DS011-TRJR-480024 011-PDV-0146
2"-CLD-011014313-101CH2S-P
4"
2"-CLD-011014305-101CH2S-P AG
4" UG
DS011-TRJR-480026
13
4953
DS011-TRJR-480026 6083 011-TV-0079 DS011-TRJR-480026
12
4954
11
0.2% UG
6"-CLD-011078317-101CH2S-N 10
AG 011-D-0002
4"-CLD-011007302-101CH2S-P
4"
9
DS011-TRJR-480012
6"-CLD-011078301-101CH2S-N
2817 011-G-0024 A
2"-CLD-011007304-101CH2S-P
4"
8
DS011-TRJR-480013 2823
011-D-0002
2"-CLD-011007313-101CH2S-P
4"
2"-CLD-011007308-101CH2S-P
4"
DS011-TRJR-480013
10"-RES-011015004
011-E-0020 A/B
011-E-0019 D/E
10"-HFO-011015004
011-E-0019 A/B
011-E-0018 C/D
011-E-0016 B
011-E-0018 A
011-E-0018 A
011-E-0016 A
DS011-TRJR-480029
DS011-TRJR-480029
DS011-TRJR-480029
DS011-TRJR-480028
DS011-TRJR-480028
DS011-TRJR-480028
DS011-TRJR-480027
DS011-TRJR-480025
DS011-TRJR-480027
DS011-TRJR-480027
DS011-TRJR-480025
7771
7770
7779
7698
7704
7734
7709
7762
7706
7707
7759
6
2824
DS011-TRJR-480012
011-E-0020 D/E
7
011-G-0024 B
2"-CLD-011007303-101CH2S-P
4"
6392 011-D-0002
5
DS011-TRJR-480012
4"
2818
011-FV-0003
2"-CLD-011004302-101CH2S-P
4
DS011-TRJR-480008 4882
011-E-0020 D/E
10"-CRD-011015008
011-E-0020 A/B
011-E-0019 D/E
12"-CRD-011015001
011-E-0019 A/B
011-E-0018 C/D
011-E-0017 B
011-E-0016 B
011-E-0017 A
011-A-0002
011-E-0016 A
011-SC-0018
DS011-TRJR-480029
DS011-TRJR-480029
DS011-TRJR-480029
DS011-TRJR-480028
DS011-TRJR-480028
DS011-TRJR-480028
DS011-TRJR-480027
DS011-TRJR-480026
DS011-TRJR-480025
DS011-TRJR-480026
DS011-TRJR-480048
DS011-TRJR-480025
DS011-TRJR-480274
7780
7783
7773
7699
7703
7733
7708
7674
7761
7675
3301
7760
8284
2"-CLD-011200316-101CH2S-N
4"
AG
3
2"-CLD-011078346-101CH2S-P 2"-FLO-011078320-101CS1P-N
UG 101CH2S
6"-CLD-011078317-101CH2S-N
1"-HFO-011027132
1
16
2"-HFO-011013027
DS011-TRJR-480027
011-FV-0049
0.2 %
9 8
2"-CLD-011015327-101CH2S-P
101CH2S 101CS1P
2"-FLO-011078319-101CS1P-N
10
2"-CLD-011078345-101CH2S-P
11
3/4"
17
DS011-TRJR-480024
011-FV-0063
2"-CLD-011014312-101CH2S-P
4"
7710
UG AG
2"-CLD-011027308-101CH2S-P
12
2"-CLD-011013320-101CH2S-P
2"-CLD-011014320-101CH2S-P
DS011-TRJR-480027
14
D
2"-CLD-011013315-101CH2S-P
DS011-TRJR-480024
15
13
18
011-E-0015 A/B 7788
4"
4"
2"
4"
16
0.2%
6"-CLD-011078335-101CH2S-N
17
4"
DS011-TRJR-480066
D
101CS1P
FLO
2
7835
3/4" 1
CLD DRAIN
9408
FROM CLD HEADER
6"-CLD-011078301-101CH2S-N
DS011-TRJR-480228 5481
1"-HFO-011027123 DS011-TRJR-480066
6"-CLD-011078301-101CH2S-N
7673
CLD DRAIN TO CLD HEADER DS011-TRJR-480232 5334
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1 DELETED 2- DELETED.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
00
29-JAN-2010
IFD
IFD: ISSUED FOR DESIGN
ARV / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080 011-077
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CLOSED DRAIN UTILITY DISTRIBUTION ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480231 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480231 2271-011-PID-0021-078
REV: 05
Sheet: 7 of 8
SCALE: NONE Format:
A1
41
41
011-D-0014 CLOSED DRAIN DRUM
40
40
TRIM: SLP-011078601-101CH2S TRIM: SLP-011078602-103CH2S INSULATION: N
39
39
38
38
37
37
36
36
35
35
34
34
33
33
HPT 6"-LFL-011078301-101CH2F-N
32
NO POCKET
29
32
2141
NOTE 9
31 30 29
14
1"
2"x1"
2"-LPC-011078301-101CS1P-H
31
LO
Z 0009
30
UC 2"x1"
2"-LPS-011078302-101CS1P-H
3/4" V
5338
3/4" D
28
3/4" D
27
2"x3/4"
26
2"-CLD-011078334-101CH2S-P
28
2"x3/4" NC 3/4"
25
2"-LPS-011078301-101CS1P-H
24
29
11
27
25
3/4" V NOTE 8 UC 0318
3/4" D
22
2"
21
T1
20
TI
LI 0083
H
H
TI 0370
MG
L
TT
0084 LL
02
M LT
0.2 %
LO
14
NOTE 2 1"
13
LO
734mm
GRADE
1" V
15
H
2"
2"
B1
A2
ZC
UC
0360
0318
NOTE 11
3/4"
NOTE 3,12
6"
S1
6" V
W
V1
L1
0343
3/4"
INST. PIPING
21
PT
20
INST. PIPING
19 18
2"
0084 NOTE 3
2"
TT 0370
PI 0285
011-G-0025-A
0262 16
23
0343
22
MCC
NOTE 5 LT 0083
PI
0025 A
LI
MIN
NOTE 5
18 17
ZC 0360
PUMP STOP
TYPICAL 10
0262
19
24
HH
5337
23
26
ZC 0360
L2
24"
24"
4"
NOTE 6 24"
M2
K1
S3
K2
NOTE 3
17
NOTE 7 24"
4"
24"
S2
M1
1"
D
NOTE 6
16
NOTE 1 15
6" BW
A1
14
D
13
10"-101CH2S (TRIM LINE)
12
12
11
11
011-D-0014
10
10
NOTE 13
7 6 5
910 mm
8
4"-SLP-011078001-103CH2S-P
9
6"-CLD-011078301-101CH2S-N
9
1%
8 7 6 5
4
4
3
SLOP OIL
2
DS011-TRJR-480136 3584
3
TO B.L.
2
1
1
CLD DRAIN FROM HEADER DS011-TRJR-480231 5334
011-G-0025-A DRAIN SUMP PUMP INSULATION: N
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
RDP / MAC
JAL
00
30-DEC-2009
IFD
IFD: ISSUED FOR DESIGN
MVF / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
APPR/AUTH BY
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PRECEDED BY 011 (EX. 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND / OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT / PIPING TO BE DRAINED. 5- LINES TO BE TRACED UP TO THE LAST VALVE, TRACING REQUIREMENTS ARE SHOWN ON PROCESS PID.
NOTES
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
011-G-0025-A m³/h barg bar barg °C kg/m³
50.0 9.40 - 13.73 17.23- 13.73 22.00 NOTE 4 920.0
011-D-0014 TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
mm mm barg °C barg °C
9700.0 3700.0 0.50 NOTE 4 3.50 200.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
10 DELETED 1- PIT FILLED WITH SAND AND CLOSED TOP WITH CONCRETE COVER. CATHODIC PROTECTION TO BE PROVIDED. 2- EXTENDED VALVE STEM. 3- CONNECTION FOR PORTABLE PUMP. 4- OPERATION TEMPERATURE: AMB TO 170°C. 5- LEVEL MEASUREMENT TYPE RADAR FILOGUIDE. 6- NOZZLE FOR WAREHOUSE SPARE PUMP. 7- CONNECTION FOR SAMPLING WELL. 8- PUMP STOPPING UPON L(UC-0318) AND LL(ZC-0360) SET POINT, STARTING MANUALLY BY OPERATOR. 9- MAKE CONNECTION ON TOP OF LINE. 11- PUMP CAN BE ONLY STARTED IF THE TEMPERATURE IN D-0014 IS LESS THAN 170ºC(TAHH-0370), OR LOW LOW LEVEL (LALL-0084) NOT TRIPPED 12- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JER-DS011-TRJR-480249 13- FOR NOZZLES DETAILS, ALIGNMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING
COMPANY STATUS
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CLOSED DRAIN DRUM
011-074 011-076 Item Tags :
011-075 011-080 011-077 011-079 011-071
011-D-0014,
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
011-G-0025-A
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480232.pid
Discipline: PRO
SA-JER-DS011-TRJR-480232 2271-011-PID-0021-078
REV:
05
Sheet: 8 of 8
SCALE: NONE Format:
A1
41 40
011-D-0025 AMINE DRAIN DRUM
011-S-0005 RICH AMINE FILTER
TRIM: LFL-011079601-101CH2F / AMD-011079602-103CH2S INSULATION: H
TRIM: AMD-011079603-103CH2S
41 40
39 38
9401
9404
DS011-TRJR-480275
DS011-TRJR-480275
011-SC-0044
011-SC-0031
HPT
38
29
NO POCKET
2033
37
37
NOTE 10
D
3/4"
9402
HPT
DS011-TRJR-480275
36
N
LO
4"-LFL-011079301-101CH2F-N
39
3/4"-LFL-011079302-101CH2F-N
011-SC-0048
36
29
3/4" 32
6" V
3/4"-AMD-011079008-101CH2S-P
4"
3/4" D
2"x1"
2"-AMD-011079315-101CH2S-P 3/4" D
3/4" D
A2
1"-AMD-011079313-101CH2S-P
A3
2"
3/4" D
2"
PIPING INST.
2"
3/4" V NC
3"-AMD-011079301-101CH2S-P
LO
LO
3"
LO
0132
H
0319
L
26
PUMP STOP
1/4" D LI 0133
24
ID 24"
2"
L3B
23
21
1/4" D
T
2"
DS011-TRJR-480094
DS011-TRJR-480095
DS011-TRJR-480095
7799
4668
4672
4676
3"-AMN-011036004
011-C-0007
011-G-0023-B
011-G-0027
011-S-0005
DS011-TRJR-480137
DS011-TRJR-480094
DS011-TRJR-480095
DS011-TRJR-480233
DS011-TRJR-480233
7801
4660
4675
4687
4698
9
D
NC
22
0422 21 20
PDT 0422
INST. 3/4"
23
H
PDI
PIPING
2"-AMD-011079007-101CH2S-P
101CH2S 101CS1P
2"-AMD-011079004-103CH2S-P
101CH2S 103CH2S
D
LPT
19 18
PI
PI
0440
0441 17
3/4"
3/4"
3/4"
3/4"
INST. PIPING 2"
M 8"
V
3/4"
3/4"
3/4"
3/4"
16 15
V
2"-AMD-011079002-103CH2S-P
OLW
101CH2S 103CH2S
3/4" 2"-AMD-011079314-101CH2S-P
2"-AMD-011079005-103CH2S-P 6
MIN.
3/4"
3/4" UC INST.
PI 0316
PIPING
PI
3/4" 2"x1"
LPT /4" 1"x3
4
1-1/2"
NOTE 9
0417
3/4"-OLW-011079303-101CS1P-N TO GRADE INST. PIPING
3/4"
5
101CH2S 101CS1P
NOTE 6
2"-AMD-011079309-103CH2S-P
INST. PIPING
M
PIPING INST. 3/4"
4698
NOTE 3,11
PT
PI
0419
0419
10 9 8
OLW
AMD
011-G-0027
3
11
103CH2S 101CH2S
2"-AMD-011079303-101CH2S-P
12
3/4" D
3/4"
3/4"
13
TRUCK CONNECTION NOTE 4
011-S-0005
3/4" D
1-1/2"
2"-AMD-011079006-103CH2S-P
MIN.
TL
S D1
3/4" D LPT
3/4"
B1
A1
2"-AMD-011079308-103CH2S-P
UC
TRUCK CONNECTION NOTE 4 2"x3/4"
8 7
14
MIN.
MIN.
DS011-TRJR-480137
2"-AMD-011079303-101CH2S-P
2"-AMD-011036303-101CH2S-P
2"-AMD-011036305-101CH2S-P 011-LV-0074
24
2"
2"-AMD-011079001-101CH2S-P
10
011-G-0023-A
1/4"
2" L1A
D 2"
2"-OLW-011079301-101CS1P-N
11
011-C-0007
A4
B1
2"-AMD-011079318-101CH2S-P
12
3"-AMN-011099001
2"-AMD-011079302-101CH2S-P
13
2"-AMD-011036304-101CH2S-P
14
2"-AMD-011036302-101CH2S-P
2"-AMD-011099302-101CH2S-P
15
2"-AMD-011036306-101CH2S-P
2"-AMD-011099301-101CH2S-P
18
L2A
6300 mm
3/4" V
16
2"
S
25
NOTE 12 011-SC-0048 TYPE 31 SC DV
1/4" D
2"
UC
17
LG 0134
L3A
2"-AMD-011079316-101CH2S-P
19
LT 0133
MAG
2"
MIN
20
LT 0132
2"
TT 0457
ZC 0361 LL
M1
TI 0457
27
2"
L2B
25
22
28
UC
NOTE 2
L1B
A1
3/4" D
3/4" D
29
2" LI
26
30
2"-AMD-011079003-103CH2S-P
2150
28
PIPING INST.
V1
NOTE 13
3/4"-OLW-011079304-101CS1P-N
FI 0158
2"-DWA-011079301-101SR0P-N
5
31
B2
101CS1P
30 29
011-D-0025
101SR0P 101CH2S
READABLE
27
33
103CH2S
31
101CH2F 101CH2S NC
LO
1"-AMD-011079311-103CH2S-P
32
34
3/4"-AMD-011079312-103CH2S-P
33
35
NOTE 10
2"-AMD-011200301-101CH2S-P
2"-AMD-011200302-101CH2S-P
34
2"-AMD-011200303-101CH2S-P
3956
35
7 6 5 4 3
1/2"-AMD-011079306-103CH2S-P AMINE
2
1-1/2"-AMD-011079306-103CH2S-P
1
DS011-TRJR-480095 3465
3/4"-OLW-011079302-101CS1P-N
TYPICAL 3
UC 0319
2"x1-1/2"
103CH2S 101CH2S
0027
011-G-0027 AMINE DRAIN PUMP
2"-AMD-011079302-101CH2S-P
OLW
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MCG / STG
RDP / MAC
JAL
00
30-DEC-2009
IFD
ISSUED FOR DESIGN
MRM / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
AMD 4687
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- DRAIN VALVE ON EQUIPMENT AND / OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT / PIPING TO BE DRAINED.
NOTES PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND. DRUM TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
011-G-0027 m³/h barg bar barg °C kg/m³
2.2 7.70 7.00 13.10 71.00 1034.0 011-D-0025
mm mm barg °C barg °C
2500.0 900.0 0.30 AMB TO 71 3.50 NOTE 5 100.00
FILTERS TYPE DES. CAPACITY OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP.
m³/h barg °C barg °C
011-S-0005 BASKET 2.2 7.70 71.00 13.10 100.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
8 DELETED. 1- VALVE TO BE LOCATED AT LEAST 7.5m BEYOND THE EDGE OF ANY FIRE HAZARDOUS ZONE. 2- PUMP, STOPPING UPON L (UC-0319) AND LL (ZC-0361) SET POINTS, STARTING MANUALLY BY OPERATOR. 3- WARE HOUSE SPARE PUMP. 4- TRUCK CONNECTIONS TO BE LOCATED IN A CURBED AREA AND CLOSED TO AN ACCESS. 5- HALF VACUUM AT 150ºC. 6- FLANGE FOR POSSIBLE PUMP ISOLATION BY BLIND FLANGE. 7- DISMOUNTABLE PIPING FOR POSSIBLE CLEAN-OUT BY STEAM INJECTION. 9- CHECK VALVE SHALL BE INSTALLED HORIZONTALLY. 10- MAKE CONNECTION ON TOP OF LINE. 11- FOR FURTHER INFORMATION SEE PUMPS AUXILIARY DETAILS DIAGRAM: SA-JER-DS011-TRJR-480251. 12- FOR FURTHER INFORMATION SEE SAMPLE DETAILS DIAGRAM: SA-JER-DS011-TRJR-480275. 13- FOR NOZZLES DETAILS, ALIGNEMENT AND HEIGHT OF LEVEL INSTRUMENTS SEE MECHANICAL DRAWING.
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
1
NOTE 7
250mm MIN.
MG
3/4"
103CH2S 101CS1P
MIN.
MCC
MIN.
ZC 0361
2
TO B.L. RICH AMINE
DESCRIPTION
N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER AMD AMINE CLOSED DRAIN FLO FLUSHING OIL CND TURBINE CONDENSATE
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 AMINE CLOSED DRAIN UTILITY DISTRUBUTION
011-074 011-076 Item Tags :
011-075 011-080 011-079 011-077 011-071
011-D-0025, 011-S-0005, 011-G-0027
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480233 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480233 2271-011-PID-0021-079
REV: 05
Sheet: 1 of 1
SCALE: NONE Format:
A1
41 40
2"
AWS
AWR
DS011-TRJR-480239
DS011-TRJR-480239 2443
8"-CWS-011080302-301FE0W-N
39 38 37 36 35
011-G-0002A/B LUBE OIL CONSOLE DS011-TRJR-480256
1-1/2"-CWR-011450301-101CS1P-N
8"-CWR-011080302-301FE0W-N
2442
41
2"
2"-CWR-011450301-101CS1P-N
40
N
6886
2"-CWS-011450301-101CS1P-N
39
011-G-0002A/B LUBE OIL CONSOLE DS011-TRJR-480256
1-1/2"-CWS-011450301-101CS1P-N
38
6885
37
101CS1P AG 301FE0W UG 2"-CWR-011450302-301FE0W-N
36
2"-CWS-011450302-301FE0W-N 35
3"-CWS-011171352-301FE0W-N 34
34
33
301FE0W UG
2"-CWS-011171352-301FE0W-N
101CS1P AG 2"
2"-CWS-011171305-101CS1P-N
2"x1"
011-G-0002-A
33
DS011-TRJR-480245 2968
32
32
3"-CWR-011171352-301FE0W-N 31
31
2"
2"-CWR-011171352-301FE0W-N
30
2"-CWR-011171305-101CS1P-N
2"x1"
011-G-0002-A
NOTE 3 29
30
DS011-TRJR-480245 2969
29
2" 2"
2"-CWS-011171351-301FE0W-N
28
2"-CWS-011171306-101CS1P-N
2"x1"
011-G-0002-B
28
DS011-TRJR-480245
NOTE 3 27
2970
27
2" 2"
2"-CWR-011171351-301FE0W-N
26
2"-CWR-011171306-101CS1P-N
2"x1"
011-G-0002-B
26
DS011-TRJR-480245 2971
25
25
2"
2"-CWS-011446303-301FE0W-N
2"-CWS-011446301-101CS1P-N
24
24 011-G-0001-A/B LUBE OIL CONSOLE DS011-TRJR-480254
1-1/2"-CWS-011446301-101CS1P-N
23
2"
2"-CWR-011446307-301FE0W-N
22
UG 301FE0W
21
2972
2"-CWR-011446301-101CS1P-N
AG 101CS1P
22 011-G-0001-A/B LUBE OIL CONSOLE DS011-TRJR-480254
1-1/2"-CWR-011446301-101CS1P-N
18 17 16 15
2"-CWS-011171348-301FE0W-N
301FE0W UG
18
101CS1P AG 2"
2"-CWS-011171301-101CS1P-N
2"x3/4"
011-G-0026-A
17
DS011-TRJR-480249 2976
2"
2"-CWR-011171348-301FE0W-N
2"-CWR-011171301-101CS1P-N
2"x3/4"
16
011-G-0026-A
15
DS011-TRJR-480249 2977
NOTE 3 2"
14
2"
2"-CWS-011171347-301FE0W-N
14
2"-CWS-011171302-101CS1P-N
2"x3/4"
011-G-0026-B
13
13
DS011-TRJR-480249
NOTE 3 12
2978
12
2"
11
PI
PT
0442
0442
2"
2"-CWR-011171302-101CS1P-N
011-G-0026-B
PIPING INST.
2"
PI 0424
2"
10
PI 0425
9
2"
4
CL300 2"
2"
6
NOTE 4
2" 4
D
2
ORIGINAL SIGNED IN PROJECT FILE 1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
RDP / MAC
JAL
00
29-JAN-2010
IFD
IFD : ISSUED FOR DESIGN
JCP / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
MIN.
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- IP´S INFORMATION OF TWIN UNIT CAN BEFOND IN P&ID SA-JER-SA011-TRJR-480139.
NOTES 1,2 DELETED 3- FUTURE CONNECTION 4- FABRICATED, ERECTED BUT NOT IN USE.
3
AUXILIARY COOLING WATER SA-JER-IP691-TPIT-481056
IP-6039-S 8"CWR-691309307-301FE0P-N
AUXILIARY COOLING WATER SA-JER-IP691-TPIT-481056
IP-6040-S 8"CWS-691309307-301FE0P-N
INTERCONNECTING
7
5
MIN.
UNIT 011 UNIT 691 B.L.
301FE0P 301FE0W
8
TI 0458 2"-CWR-011230304-301FE0W-N
D
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
NOTE 4
301FE0P 301FE0W
FT 0159
AWS
5
FI 0159
CL300 2"
AWR
6
TT 0459
INSTRUMENT PIT
7
TI 0459
INSTRUMENT PIT
2"-CWS-011230304-301FE0W-N
8
11
2979
PIPING
10 9
2"
2"-CWR-011171347-301FE0W-N
2"x3/4"
DS011-TRJR-480249
INST.
1
20 19
8"-CWR-011080302-301FE0W-N
8"-CWS-011080302-301FE0W-N
19
2
21
2973
20
3
23
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CWS, CWR UTILITY DISTRIBUTION
Item Tags :
011-075 011-080
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480237.pid
Discipline: PRO
SA-JER-DS011-TRJR-480237 2271-011-PID-0021-080
REV:
05
Sheet: 1 of 4
SCALE: NONE Format:
A1
41
011-G-0004/B LUBE OIL CONSOLE DS011-TRJR-480258
011-G-0004-B
011-G-0004-B
DS011-TRJR-480245
011-G-0004/A LUBE OIL CONSOLE DS011-TRJR-480258
DS011-TRJR-480245
DS011-TRJR-480245
2608
6871
6872
2610
2611
DS011-TRJR-480245 2609
2"-CWR-011171317-101CS1P-N 2"x1"
37 36 35 34 33 32
2"-CWR-011171318-101CS1P-N 2"x1"
38
N
39 38 37
3"-CWS-011460301-101CS1P-N
011-G-0004-A
2"-CWS-011171318-101CS1P-N 2"x1"
011-G-0004-A
2"-CWS-011171317-101CS1P-N 2"x1"
39
40
36
3"-CWR-011460301-101CS1P-N
40
1-1/2"
1-1/2"
41
35 34 33 32
23
3"
3"
3"-CWS-011460302-301FE0W-N
3"-CWR-011460302-301FE0W-N
2"
2"
DS011-TRJR-480239 5487
24
AWR
25
FROM AWR HEADER
26
2"-CWS-011171363-301FE0W-N
6"-CWS-011171395-301FE0W-N
2"-CWR-011171363-301FE0W-N
2"
TO AWS HEADER
27
DS011-TRJR-480239 5488
28
AWS
29
2"-CWS-011171364-301FE0W-N
AG 101CS1P UG 301FE0W
30
2"
31
2"-CWR-011171364-301FE0W-N
31
101CS1P AG 301FE0W UG
30 29 28 27 26 25
6"-CWS-011171393-301FE0W-N 6"-CWR-011171395-301FE0W-N
24
6"-CWR-011171393-301FE0W-N UG 301FE0W 2"-CWR-011171362-301FE0W-N
22
AG 101CS1P 2"
23
2"-CWR-011171315-101CS1P-N
2"x3/4"
011-G-0003-A
22
DS011-TRJR-480251 2614
21
21
2"
2"-CWS-011171362-301FE0W-N
20
2"-CWS-011171315-101CS1P-N
2"x3/4"
011-G-0003-A
20
DS011-TRJR-480251 2613
19
19
2"
2"-CWR-011171361-301FE0W-N
18
2"-CWR-011171316-101CS1P-N
2"x3/4"
011-G-0003-B
18
DS011-TRJR-480251
2"-CWR-011012301-101CS1P-N
17
2"x1"
2616
FROM 011-AT-00201
17
DS011-TRJR-480023
NOTE 2
2" 16
2"
2"-CWS-011171361-301FE0W-N
8257
2"-CWS-011171316-101CS1P-N
2"x3/4"
16
011-G-0003-B DS011-TRJR-480251
15
2"-CWS-011012301-101CS1P-N
15
TO 011-AT-0020
2615
DS011-TRJR-480023
6"x3"
NOTE 2
2"
14
301FE0W UG
6"x3"
13
2"x1"
101CS1P AG
8256
14 13
3"-CWR-011171393-301FE0W-N
12
UG 301FE0W
3"-CWS-011171393-301FE0W-N
11
AG 101CS1P
10
4
UG 301FE0W AG 101CS1P
2"x3/4" 2"-CWS-011171313-101CS1P-N
2"x3/4"
1
011-G-0028-A
011-G-0025
DS011-TRJR-480249
DS011-TRJR-480249
2618
2617
011-G-0028-B
011-AS-0002
9
2"-CWR-011171354-301FE0W-N 2"
2"-CWR-011230302-101CS1P-N
2"x1"
DS011-TRJR-480290
301FE0W 101CS1P UG AG
2"-CWS-011171354-301FE0W-N
8
2620
7
2"x3/4"
2"-CWR-011171308-101CS1P-N
6
NOTE 2
2"
2"-CWR-011171353-301FE0W-N
DS011-TRJR-480250
5
2628
2" 011-G-0028-B
2"-CWS-011171356-301FE0W-N
2"x3/4"
2"-CWS-011171307-101CS1P-N
NOTE 2
4
2"
2"-CWS-011171353-301FE0W-N
DS011-TRJR-480250
AG 101CS1P 2"
101CS1P AG
2627
2"-CWS-011171399-101CS1P-N
2"x3/4"
3
301FE0W UG
2
011-G-0024-A DS011-TRJR-480250
1
2629
2"-CWR-011171356-301FE0W-N
2"
2"-CWR-011171309-101CS1P-N
2"x3/4"
011-G-0024-A DS011-TRJR-480250 2630
2"-CWS-011171355-301FE0W-N
2"
2"
2"-CWS-011171310-101CS1P-N
2"-CWR-011171310-101CS1P-N
2"x3/4"
2"x3/4"
05
13-MAR-2013
AB
DS011-TRJR-480250
04
30-SEP-2011
2631
03
011-G-0024-B
011-G-0024-B DS011-TRJR-480250
UG 301FE0W
AG 101CS1P
GENERAL NOTES
NOTES
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
10
2"
1- DELETED. 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480019.
1. DELETED. 2- FUTURE CONNECTION
2619
2625
2"-CWR-011171355-301FE0W-N 011-G-0025
2"
11
011-AS-0002 DS011-TRJR-480290
2"-CWR-011230305-301FE0W-N 2"x3/4" 2"-CWS-011171309-101CS1P-N
2"x1"
DS011-TRJR-480250
UG 301FE0W
2"-CWR-011171313-101CS1P-N
2
2"
2"-CWR-011171307-101CS1P-N
2626
301FE0W UG 101CS1P AG
3
2"x3/4"
2"-CWS-011230302-101CS1P-N
DS011-TRJR-480250
3"-CWS-011171393-301FE0W-N
5
3"-CWR-011171393-301FE0W-N
6
2"
7
2"-CWR-011171360-301FE0W-N
8
2"
9
2"-CWS-011171360-301FE0W-N
011-G-0028-A
2"
2"-CWS-011230305-301FE0W-N
UG 301FE0W
12
AG 101CS1P
2632
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
RDP / MAC
JAL
00
29-JAN-2010
IFD
IFD: ISSUED FOR DESIGN
VJS/STG
RDP/MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080 011-077
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 AWS.AWR UTILITY DISTRIBUTION
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480238 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480238 2271-011-PID-0021-080
REV: 05
Sheet: 4 of 4
SCALE: NONE Format:
A1
41
41 011-G-0014B
011-G-0012A
011-G-0012B
011-G-0010A
011-G-0010B
011-G-0008A
011-G-0008B
DS011-TRJR-480247
DS011-TRJR-480263
DS011-TRJR-480263
DS011-TRJR-480246
DS011-TRJR-480246
DS011-TRJR-480252
DS011-TRJR-480252
2423
2425
2427
2429
2433
2439
2436
2438
N
39 011-G-0010A
011-G-0010B
011-G-0008A
011-G-0008B
DS011-TRJR-480247
DS011-TRJR-480247
DS011-TRJR-480263
DS011-TRJR-480263
DS011-TRJR-480246
DS011-TRJR-480246
DS011-TRJR-480252
DS011-TRJR-480252
2424
2426
2428
2431
2432
2434
2435
2437
2"x1-1/2" 2"-CWS-011171332-101CS1P-N
2"
2"-CWS-011171377-301FE0W-N
2"x1-1/2" 2"-CWR-011171332-101CS1P-N NOTE 2
2"
2"-CWR-011171377-301FE0W-N
DS011-TRJR-480250 2509
12
011-G-0013B DS011-TRJR-480250
11
2510
2"x1-1/2" 2"-CWS-011171343-101CS1P-N
2"
DS011-TRJR-480252
9
2515
8
DS011-TRJR-480252
011-G-0009A
2"x1-1/2" 2"-CWR-011171343-101CS1P-N
2"
2"-CWS-011171390-301FE0W-N
2"-CWR-011171390-301FE0W-N
011-G-0009B
2"x1-1/2" 2"-CWS-011171344-101CS1P-N
2"
DS011-TRJR-480252
1
011-G-0009B
DS011-TRJR-480238 5488
TO AWR HEADER
DS011-TRJR-480238 5487
AWR
AG
6"-CWR-011171395-301FE0W-N
6"-CWS-011171395-301FE0W-N
UG
101CS1P 2"-CWR-011171366-301FE0W-N
2"-CWS-011171366-301FE0W-N
2"-CWR-011171365-301FE0W-N
2"-CWR-011171370-301FE0W-N
2"-CWS-011171370-301FE0W-N
AWS
2"-CWR-011171320-101CS1P-N
2"-CWS-011171320-101CS1P-N
2"-CWR-011171319-101CS1P-N
2"-CWS-011171319-101CS1P-N
2"-CWR-011171324-101CS1P-N
2"-CWS-011171324-101CS1P-N
2"-CWR-011171323-101CS1P-N 2"-CWR-011171369-301FE0W-N
301FE0W
101CS1P 301FE0W
AG UG
2"-CWS-011171369-301FE0W-N
27 26 25
19
17
UG
301FE0W
18
16
AG
2"
20
101CS1P
2"-CWS-011171368-301FE0W-N
2"-CWR-011171368-301FE0W-N
2"
2"-CWS-011171367-301FE0W-N
2"-CWR-011171367-301FE0W-N
2"-CWS-011171391-301FE0W-N
21
15 14 13 12 11 10 9
2"-CWS-011171389-301FE0W-N
011-G-0011B
011-G-0005A
011-G-0005B
DS011-TRJR-480250
DS011-TRJR-480253
DS011-TRJR-480253
2514
2506
2504
7
2"x1-1/2" 2"-CWR-011171344-101CS1P-N
2"
2"-CWR-011171389-301FE0W-N
011-G-0011B
011-G-0005A
011-G-0005B
DS011-TRJR-480250
DS011-TRJR-480253
DS011-TRJR-480253
2513
2505
2503
5
DS011-TRJR-480240 5528
2518 FROM AWR HEADER
2
28
6
DS011-TRJR-480252
AWS
3
TO AWS HEADER
4
29
2517
DS011-TRJR-480240 5527
5
AWR
6
30
8
2516
7
AG
2"x1-1/2"
011-G-0009A
10
2"
31
2"-CWS-011171322-101CS1P-N
011-G-0013B
2"
32
2"x1"
NOTE 2 13
UG
2"-CWR-011171346-101CS1P-N
2508
2"-CWR-011171322-101CS1P-N
AG
DS011-TRJR-480250
14
2"x1"
2"-CWR-011171378-301FE0W-N
2"
2"
2"-CWS-011171321-101CS1P-N
011-G-0013A
2"x1"
2"x1-1/2" 2"-CWR-011171331-101CS1P-N
2507
2"
2"-CWS-011171378-301FE0W-N
2"-CWR-011171321-101CS1P-N
2"
DS011-TRJR-480250
15
301FE0W 101CS1P
2"-CWR-011171374-301FE0W-N
2"x1-1/2" 2"-CWS-011171331-101CS1P-N
2"x1"
011-G-0013A
16
UG 301FE0W
2"
17
AG 101CS1P
2"-CWS-011171346-101CS1P-N
UG 301FE0W
2"x1-1/2"
AG 101CS1P
2511
2"-CWR-011171392-301FE0W-N
2"-CWR-011171391-301FE0W-N
2"
2"
2"x1-1/2" 2"-CWR-011171345-101CS1P-N
011-G-0011A DS011-TRJR-480250
2"
34
23
301FE0W
2512
UG
2"-CWS-011171392-301FE0W-N
19 18
2"
2"
35
33
8"x6"
8"-CWR-011080302-301FE0W-N
2"
8"-CWS-011080302-301FE0W-N
2"x1-1/2" 2"-CWS-011171345-101CS1P-N
011-G-0011A DS011-TRJR-480250
2"
36
22
UG 301FE0W
21 20
2"
37
24
8"x6" AG 101CS1P
2"-CWS-011171323-101CS1P-N
2"-CWR-011171328-101CS1P-N
2"-CWS-011171328-101CS1P-N
2"-CWR-011171327-101CS1P-N
2"-CWS-011171327-101CS1P-N
2"-CWS-011171330-101CS1P-N
2"-CWR-011171329-101CS1P-N
23 22
NOTE 2
NOTE 2 2"
38
8"x6"
8"x6"
24
101CS1P
UG
2"-CWS-011171374-301FE0W-N
25
2"
2"
2" 2"-CWR-011171373-301FE0W-N
26
2"-CWS-011171373-301FE0W-N
27
2"
2" 2"-CWR-011171376-301FE0W-N
28
2"
2"
2"
2"-CWS-011171376-301FE0W-N
AG 29
6"-CWS-011171395-301FE0W-N
6"-CWR-011171395-301FE0W-N
30
NOTE 2
NOTE 2
2"-CWR-011171375-301FE0W-N
TO AWS HEADER
DS011-TRJR-480240 5525
31
301FE0W 101CS1P 2"-CWS-011171375-301FE0W-N
32
DS011-TRJR-480240 5526
33
AWR
34
FROM AWR HEADER
AWS
35
2"-CWS-011171329-101CS1P-N
36
2"-CWR-011171330-101CS1P-N
37
39
2"x1-1/2"
011-G-0012B
2"x1-1/2"
011-G-0012A
2"x1-1/2"
011-G-0014B
2"x1-1/2"
011-G-0014A
2"-CWS-011171365-301FE0W-N
38
40
FROM AWS HEADER
40
011-G-0014A DS011-TRJR-480247
011-G-0007A
2"x1"
4
2"-CWS-011171325-101CS1P-N
2"
DS011-TRJR-480245
2"-CWS-011171372-301FE0W-N 3
2553 011-G-0007A
2"x1" 2"-CWR-011171325-101CS1P-N
2"
2"-CWR-011171372-301FE0W-N
2"x1"
2"-CWS-011171326-101CS1P-N
2"
2"-CWS-011171371-301FE0W-N
2"x1" 2"-CWR-011171326-101CS1P-N
2"
2"-CWR-011171371-301FE0W-N
DS011-TRJR-480245
2
2554 011-G-0007B
1
DS011-TRJR-480245 2551 011-G-0007B DS011-TRJR-480245
101CS1P AG
2552
301FE0W UG
6"-CWR-011080302-301FE0W-N 6"-CWS-011080302-301FE0W-N
AWS
AWR
DS011-TRJR-480237
DS011-TRJR-480237
2442
2443
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
RDP / MAC
JAL
00
29-JAN-2010
IFD
IFD: ISSUED FOR DESIGN
MVF / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
GENERAL NOTES
1 DELETED 2- FUTURE CONNECTION
05
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS. 19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CWS, CWR UTILITY DISTRIBUTION ORIGINAL SIGNED IN PROJECT FILE
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480239.pid
Discipline: PRO
SA-JER-DS011-TRJR-480239 2271-011-PID-0021-080
REV:
05
Sheet: 3 of 4
SCALE: NONE Format:
A1
41
41
40
011-K-0003 LUBE OIL CONSOLE DS011-TRJR-480267
011-K-0003 LUBE OIL CONSOLE DS011-TRJR-480267
39
8121
8122
N
37
35
17
2"x1"
2"x1"
011-G-0015A
011-G-0015A
011-G-0015B
011-G-0015B
011-G-0018A
011-G-0018A
011-G-0027
011-G-0027
011-G-0018B
011-G-0018B
011-G-0017A
011-G-0017A
011-G-0017B
011-G-0017B
DS011-TRJR-480253
DS011-TRJR-480253
DS011-TRJR-480253
DS011-TRJR-480247
DS011-TRJR-480247
DS011-TRJR-480251
DS011-TRJR-480251
DS011-TRJR-480247
DS011-TRJR-480247
DS011-TRJR-480245
DS011-TRJR-480245
DS011-TRJR-480245
DS011-TRJR-480245
2457
2456
2454
2453
2497
2498
2473
2474
2500
2501
2487
2488
2489
2490
UG 301FE0W
301FE0W 101CS1P
15
2"-CWS-011171384-301FE0W-N
2"
2"-CWS-011171338-101CS1P-N
2"x1"
2"-CWS-011171388-301FE0W-N
2"
2"-CWS-011171342-101CS1P-N
2"x3/4"
2"-CWR-011171384-301FE0W-N
2"-CWR-011171338-101CS1P-N
2"x1"
011-G-0017A/B LUBE OIL CONSOLE DS011-TRJR-480260
UG
25
22 21 20 19 18
16
1-1/2" 15 14
1-1/2" 13
6870
011-G-0016-B DS011-TRJR-480247
12
26
011-G-0020B DS011-TRJR-480248 2419
2"
27
6869
6353
13
28
011-G-0016-B DS011-TRJR-480247
14
29
17
011-G-0017A/B LUBE OIL CONSOLE DS011-TRJR-480260
AG 101CS1P
30
23
2"x1"
UG AG
33
24
DS011-TRJR-480253
16
3"
34
31
101CS1P AG
3"
2"-CWS-011171336-101CS1P-N
2"-CWS-011171335-101CS1P-N
2"-CWR-011171335-101CS1P-N
2"-CWS-011171334-101CS1P-N
2"x1"
2"
2"
35
32
3"-CWS-011525301-101CS1P-N
2"
2"
2"-CWR-011171336-101CS1P-N
2"
2"
2"-CWR-011171334-101CS1P-N
2"-CWS-011171398-101CS1P-N
2"-CWR-011171398-101CS1P-N
2"-CWS-011171333-101CS1P-N
2"-CWS-011171340-101CS1P-N
2"-CWR-011171333-101CS1P-N
AG
101CS1P
UG 301FE0W
301FE0W
1"-CWS-011405301-101CS1P-N
3"-CWS-011525304-301FE0W-N
3"-CWR-011525308-301FE0W-N
1"-CWR-011405301-101CS1P-N
2"-CWS-011171382-301FE0W-N
2"-CWR-011171382-301FE0W-N
2"-CWS-011171381-301FE0W-N
2"-CWR-011171381-301FE0W-N
2"-CWS-011171380-301FE0W-N
2"-CWR-011171380-301FE0W-N
2"-CWS-011171397-301FE0W-N
2"-CWR-011171397-301FE0W-N
2"-CWR-011171379-301FE0W-N
2"-CWS-011171386-301FE0W-N
2"-CWS-011171384-301FE0W-N
2"-CWR-011171384-301FE0W-N UG AG
2"
3"-CWR-011525301-101CS1P-N
18
2"
2"
2"x3/4"
19
2"
2"x3/4"
20
2"
2"x1-1/2"
21
2"-CWR-011171340-101CS1P-N
22
2"
2"x1-1/2"
23
2"
2"-CWS-011171339-101CS1P-N
24
2"x1-1/2"
25
2"
2"x1-1/2"
UG
26
2"-CWR-011171339-101CS1P-N
27
AG 101CS1P
28
301FE0W
29
301FE0W
30
101CS1P
31
2"-CWR-011171386-301FE0W-N
32
2"-CWS-011171385-301FE0W-N
2"-CWR-011171385-301FE0W-N
33
2"-CWS-011171379-301FE0W-N
AWR
6"-CWR-011171395-301FE0W-N
34
TO AWR HEADER
36 DS011-TRJR-480239 5526
36
38
DS011-TRJR-480239 5525
AWS
6"-CWS-011171395-301FE0W-N
FROM AWS HEADER
39
38 37
40
2"-CWR-011171388-301FE0W-N
2"
2"-CWR-011171342-101CS1P-N
2"x3/4"
011-G-0020B
12
DS011-TRJR-480248
6354
2420
11
2"-CWS-011171383-301FE0W-N
2"
2"-CWS-011171337-101CS1P-N
2"x1"
11
011-G-0016-A DS011-TRJR-480247
10
2"-CWS-011171387-301FE0W-N
2"
2"-CWS-011171341-101CS1P-N
2"x3/4"
011-G-0020A
10
DS011-TRJR-480248
6355
2440
2"-CWR-011171337-101CS1P-N
9
011-G-0016-A DS011-TRJR-480247
8
301FE0W UG
7
011-K-0001
2"-CWR-011171341-101CS1P-N
2"x3/4"
011-G-0020A
8
DS011-TRJR-480248
301FE0W UG AG 101CS1P
5
2"
6356
101CS1P AG
6
2"-CWR-011171387-301FE0W-N
101CS1P AG
2441
7
UG 301FE0W
3"-CWR-011035301-101CS1P-N
3"-CWR-011080302-301FE0W-N
6"x3"
6"-CWR-011080302-301FE0W-N
DS011-TRJR-480262
3"-CWS-011035306-101CS1P-N
3"-CWS-011080302-301FE0W-N
6"x3"
6"-CWS-011080302-301FE0W-N
DS011-TRJR-480262
2
2654
101CS1P AG
1
301FE0W UG
GENERAL NOTES 1- DELETED. 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
6 5 4 3 2 1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
RDP / MAC
JAL
00
29-JAN-2010
IFD
IFD: ISSUED FOR DESIGN
NPS / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
1 DELETED
DS011-TRJR-480239 5528
011-K-0001
AWS
3
TO AWR HEADER
2655
4
DS011-TRJR-480239 5527
2"x1"
2"
FROM AWS HEADER
2"-CWR-011171383-301FE0W-N
AWR
9
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CWS, CWR UTILITY DISTRIBUTION ORIGINAL SIGNED IN PROJECT FILE
Item Tags :
011-075 011-080 Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480240.pid
Discipline: PRO
SA-JER-DS011-TRJR-480240 2271-011-PID-0021-080
REV:
05
Sheet: 2 of 4
SCALE: NONE Format:
A1
41
41
40
40 FLUSHING OIL
N
DS011-TRJR-480243
39
2197
38
36 35
TO FLO HEADER
31
FLO
32
DS011-TRJR-480224 5473
34 33
38 37
6"-FLO-011077301-101CS1P-N
37
39
36 35 34 33
6"-FLO-011077301-101CS1P-N
32 31
30
30
29
29
28
28
27
27 TO CLD
26
2"-FLO-011078320-101CS1P-N
26
DS011-TRJR-480231 7835
25
25
24
24
23
011-D-0002 DS011-TRJR-480012
22
23
3"-FLO-011007301-101CS1P-N
2199
22
21
21
20
20
19
19 011-D-0001
18
DS011-TRJR-480011
3"-FLO-011006301-101CS1P-N 18
2198
17
17
16
16 011-E-0005
2"-FLO-011003303-101CS1P-N
15
DS011-TRJR-480006
MIN.
14
15
7718
14
13
13
12
12
11
11 011-G-0002-A
10
DS011-TRJR-480015
011-E-0009-B
2"-FLO-011005302-101CS1P-N
2"-FLO-011008301-101CS1P-N
2206
2203
9 8
DS011-TRJR-480015
7
3"x2"
MIN. 011-G-0002-B
10
DS011-TRJR-480010
9
3"x2"
2"-FLO-011008302-101CS1P-N
8
011-E-0009-B
2"-FLO-011005304-101CS1P-N
DS011-TRJR-480010
2200
7
2204
6
6
3"-FLO-011005301-101CS1P-N
5
5
4
4
3
3"x2"
3
011-E-0009-A
2"-FLO-011005303-101CS1P-N
DS011-TRJR-480010
2 1
2
2218 011-G-0001A DS011-TRJR-480002
2"-FLO-011001303-101CS1P-N
3"x2"
2196
1
MIN.
011-E-0009-A
2"-FLO-011005301-101CS1P-N
DS011-TRJR-480010 2205 011-G-0001B DS011-TRJR-480002
2"-FLO-011001304-101CS1P-N
2195
FLUSHING OIL FROM B.L. DS011-TRJR-480225 2242
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480019. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
24-MAY-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / STG
RDP / MAC
JAL
00
29-JAN-2010
IFD
IFD: ISSUED FOR DESIGN
VJS / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-072 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 FLO UTILITY DISTRIBUTION ORIGINAL SIGNED IN PROJECT FILE
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480242 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480242 2271-011-PID-0021-077
REV: 05
Sheet: 5 of 6
SCALE: NONE Format:
A1
41
41
40
40
39 38
CLD SUBHEADER
011-G-0004-A
011-G-0004-B
DS011-TRJR-480231
DS011-TRJR-480021
DS011-TRJR-480021
2211
2302
2303
N
39 38
3/4" 37
37
D
34 33 32
36
2"-FLO-011011302-101CS1P-N
35
2"-FLO-011011301-101CS1P-N
2"-FLO-011078308-101CS1P-N
36
CLD SUBHEADER
2"-FLO-011078315-101CS1P-N
35
DS011-TRJR-480216
MIN.
7852
34 33 32
31
31
011-E-0030-B
2"-FLO-011038308-101CS1P-N
DS011-TRJR-480100 7777
30
30
CRD-011010005 DS011-TRJR-480019
27
2"-FLO-011010301-101CS1P-N
MIN.
4"x2"
MIN.
28
29
MIN.
29
28
011-E-0030-A
2"-FLO-011038307-101CS1P-N
4"-FLO-011010301-101CS1P-N
DS011-TRJR-480100
2210
27
7776
26
26
25
2"-FLO-011038305-101CS1P-N 011-E-0010-A
24
DS011-TRJR-480016
MIN.
23
MIN.
2254
MIN.
2"-FLO-011003302-101CS1P-N
DS011-TRJR-480005
22
24
6976
2209 CRD-011003002
DS011-TRJR-480100
2"-FLO-011008303-101CS1P-N
MIN.
23
25
HOT HVGO TO DHC/MHC
22
4"-FLO-011038304-101CS1P-N
4"x2"
011-E-0030
2"-FLO-011038304-101CS1P-N
DS011-TRJR-480100
21
MIN.
20
21
2207
20
19 18 17
19
CRD-011003002
18
2"-FLO-011003301-101CS1P-N
DS011-TRJR-480005
011-E-0010
2"-FLO-011008304-101CS1P-N
2253
17
DS011-TRJR-480016 2208
16
16
15
15
14
14
4"x2"
4"-FLO-011040303-101CS1P-N
13
13 011-E-0031
12
2"-FLO-011040307-101CS1P-N
DS011-TRJR-480104
12
6374
MIN.
11
11
10
10
9
HFO-011038005
9
2"-FLO-011038306-101CS1P-N
DS011-TRJR-480100
8
6977
8
MIN.
7
7
6
6 RES-011010003
5
2"-FLO-011040306-101CS1P-N
DS011-TRJR-480104
5
6986
MIN.
4
4
3
3 011-SC-0023
2
3/4"-FLO-011200302-101CS1P-N 2
DS011-TRJR-480273
2"-FLO-011040303-101CS1P-N
011-E-031-A
011-E-031-B
011-E-031-B
DS011-TRJR-480104
DS011-TRJR-480104
DS011-TRJR-480104
DS011-TRJR-480104
2197
2219
2221
2224
2223
2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
2"-FLO-011040304-101CS1P-N
011-E-031-A
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001).
NOTES
1
FLUSHING OIL FROM B.L DS011-TRJR-480242
GENERAL NOTES
3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED.
2"-FLO-011040302-101CS1P-N
6"-FLO-011077301-101CS1P-N
1
2"-FLO-011040301-101CS1P-N
7838
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / FBL
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / FBL
RDP / MAC
JAL
00
29-JAN-2010
IFD
IFD: ISSUED FOR DESIGN
IRG/STG
RDP/MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 FLO UTILITY DISTRIBUTION ORIGINAL SIGNED IN PROJECT FILE
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480243 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480243 2271-011-PID-0021-077
REV: 05
Sheet: 6 of 6
SCALE: NONE Format:
A1
41
41
40
40
39 38
API PLAN 11/61
API PLAN 11/61
COOLING: NONE PUMP TYPE BB2
COOLING: NONE PUMP TYPE BB2
39 38
37
37
36
36
35
35
34
34
33
33
32
32
31
31
30
30
29
29
28
28
27
27
NOTE 1 TRJR VENDOR
RO RO XXXX (A) XXXX (B)
25
V
3/4"
24
26
RO RO (B) XXXX (A) XXXX
1 3/4"
1
12
23
12
4
3/4"
4
3/4"
4
4
3/4"
22
25
VENDOR TRJR
26
24
NOTE 1 CL600RF FV
23 22
2
21
2
3
20
VENDOR TRJR
3/4" D 19
3/4"
VENDOR TRJR
20
D
WATER FROM 011-G-0021 DS011-TRJR-480111
VENDOR TRJR NOTE 1
VENDOR TRJR NOTE 1
18
21
3
19 18
17
17
OLW
OLW
16
16
15
15
14
14
13
13
12
12
11
11
10
10
9
9
8
8
7 6
PUMP
TYPE
011-G-0001-A
BB2
011-G-0001-B
BB2
011-RO-XXXX-A RO-0600 RO-0620
011-RO-XXXX-B
OLW LINE No
P&ID NUMBER
PUMP
TYPE
011-G-0021-A
BB3
RO-0601
2"-OLW-011171305-101CS1P-N
SA-JER-DS011-TRJR-480002
RO-0621
2"-OLW-011171306-101CS1P-N
SA-JER-DS011-TRJR-480002
011-G-0021-B
011-RO-XXXX-A RO-0530
BB3
OLW LINE No
P&ID NUMBER
RO-0531
2"-OLW-011171307-101CS1P-N
SA-JER-DS011-TRJR-480111
RO-0536
2"-OLW-011171308-101CS1P-N
SA-JER-DS011-TRJR-480111
011-RO-XXXX-B
RO-0535
7 6
5
5
4
4
3
3
2
2
1
1
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS/ MAC
JAL
01
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS/ MAC
JAL
00
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS/ MAC
JAL
PREPARED BY
CHECKED BY
REV
LEGEND 1
CASING VENT
2
PUMP DRAIN
3
BASE PLATE DRAIN
4
FLUSH SEAL CHAMBER INLET (FI)
5
FLUSH SEAL CHAMBER OUTLET (FO)
6
BARRIER / BUFFER FLUID SEAL CHAMBER INLET (LBI)
7
BARRIER / BUFFER FLUID SEAL CHAMBER OUTLET (LBO)
8
GAS BUFFER INLET (GBI)
9
CONTAINMENT SEAL VENT (CSV)
10 CONTAINMENT SEAL DRAIN (CSD) 11 SEAL QUENCH / DRAIN (D) 12 FROM PUMP DISCHARGE 13 TO PUMP SUCTION 14 BEARING HOUSING COOLING INLET. 15 BEARING HOUSING COOLING OUTLET. This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- FOR DRAIN AND VENT DESTINATION AND DETAILS REFER TO PROCESS DRAWING.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY 011-078 011-074
PIPING AND INSTRUMENT DIAGRAM Project:
011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PUMP AUXILIARY SEAL PLAN DETAILS No 1
Item Tags :
ORIGINAL SIGNED IN PROJECT FILE
Syst./ S-Syst.:
Discipline: PRO
COMPANY Document N° Contractor/Vendor Document N°
SA-JER-DS011-TRJR-480244 2271-011-PID-0021-171
Electronic Filename SA-JER-DS011-TRJR-480244.pid REV:
03
Sheet: 1 of 11
SCALE: NONE Format:
A1
41
41
40
40
39
API PLAN 53 B COOLING: M PUMP TYPE: BB2
38
39
API PLAN 11/53 B COOLING: M PUMP TYPE: BB2
37
38
NOTE 1
37
NOTE 1
36
36
NOTE 1
35
NOTE 1
35
PI
PI
34
(B) 33
PI (B) L TRJR VENDOR
NOTE 2 CL 600RF
31 30
3/4"
NOTE 2 CL 600RF
PI
XXXX
32
PT (A) XXXX
(D) XXXX
NOTE 2 CL 600RF
29
PZV XXXX
PZV XXXX
(A)
(B)
PT XXXX (B)
PT XXXX (A)
3/4"
PI XXXX (A)
PZV XXXX
PZV XXXX
(A)
(B)
NOTE 2 3/4" CL 600RF D
26
TI XXXX
NPT 3/4" V
25
(A)
V
D
3/4" NPT
22
NOTE 4
TRJR VENDOR
25
1/2"
V
CL 600RF
3/4" NPT
CL 600RF V
011-SP-XXXX
6
20
(A)
1
V
6
CL 600RF 3/4"
6
7
(B)
7
3/4" CL 600RF
18
2
17
3 D
16
VENDOR TRJR
2"
VENDOR TRJR NOTE 4
15
TRJR
14
1
22
011-SP-XXXX (B)
21
6
7 12 4 4
011-SP-XXXX
011-SP-XXXX
19
23
(A)
(B)
(A)
21
CL 600RF
TRJR VENDOR
RO XXXX
RO XXXX
24
D NPT
V
CL 600RF
D
1/2" V
7
20 19
2 VENDOR TRJR
17
2"
HYDROCARBONS FROM 011-G-0004 DS011-TRJR-480021
18
3 D VENDOR TRJR NOTE 4
16 15
VENDOR
TRJR
OLW
VENDOR
14
OLW 32
13 12
32
CWS
32
CWR
32
CWS
13 12
CWR
RF
11
28
V
NPT V 1/2"
29
27
NPT (B)
D
NOTE 2 CL 600RF
26
D D
31
D
TI XXXX
TI XXXX (A)
NPT
24 23
3/4"
3/4"
NPT 3/4" V
(B)
(B)
32
PT XXXX
3/4"
3/4" NOTE 2 CL 600RF D
TI XXXX
(C)
PI XXXX
33
NOTE 2 CL 600RF
NOTE 6
D
27
L
30
NOTE 6 NOTE 2 CL 600RF
34
TRJR VENDOR
3/4"
NOTE 6
NOTE 6
28
PI XXXX (C)
(D) XXXX
TRJR VENDOR
L
TRJR VENDOR
PI XXXX (A)
XXXX L
RF
11
10
10
9
9
8
8
7 6 5 4 3
PUMP
TYPE
011-PI-XXXX(A)
011-PI-XXXX(B)
011-PI-XXXX(C)
011-PI-XXXX(D)
011-PT-XXXX(A)
011-PT-XXXX(B) 011-PZV-XXXX(A) 011-PZV-XXXX(B) 011-SP-XXXX(A)
011-G-0002-A
BB2
PI-0651
PI-0650
PI-0653
PI-0652
PT-0650
PT-0652
PZV-0650
PZV-0651
011-G-0002-B
BB2
PI-0671
PI-0670
PI-0673
PI-0672
PT-0670
PT-0672
PZV-0670
PZV-0671
SP-0652
011-G-0004-A
BB2
PI-0701
PI-0700
PI-0703
PI-0702
PT-0700
PT-0702
PZV-0700
PZV-0701
SP-0700
011-G-0004-B
BB2
PI-0721
PI-0720
PI-0723
PI-0722
PT-0720
PT-0722
PZV-0720
PZV-0721
SP-0702
011-G-0017-A
BB2
PI-0751
PI-0750
PI-0753
PI-0752
PT-0750
PT-0752
PZV-0750
PZV-0751
SP-0750
011-G-0017-B
BB2
PI-0771
PI-0770
PI-0775
PI-0772
PT-0770
PT-0772
PZV-0770
PZV-0771
SP-0752
SP-0650
PUMP TYPE 011-PI-XXXX(A) 011-PI-XXXX(B) 011-PI-XXXX(C) 011-PI-XXXX(D) 011-PT-XXXX(A) 011-G-0007-A 011-G-0007-B
011-PT-XXXX(B) 011-PZV-XXXX(A) 011-PZV-XXXX(B) 011-SP-XXXX(A)
RO(A)
RO(B)
BB2
PI-0801
PI-0800
PI-0803
PI-0802
PT-0800
PT-0802
PZV-0800
PZV-0801
SP-0800
0800
0801
BB2
PI-0811
PI-0810
PI-0813
PI-0812
PT-0810
PT-0812
PZV-0810
PZV-0810
SP-0810
0810
0811
7 6 5
PUMP 011-SP-XXXX(B) 011-TI-XXXX(A) 011-TI-XXXX(B)
CWS LINE No
CWR LINE No
OLW LINE No
P&ID NUMBER
4 3
011-G-0007-A
SP-0805
TI-0800
TI-0801
1"-CWS-011171325-101CS1P-N
1"-CWR-011171325-101CS1P-N
2"-OLW-011171313-101CS1P-N
SA-JER-DS011-TRJR-480051
011-G-0007-B
SP-0815
TI-0810
TI-0811
1"-CWS-011171326-101CS1P-N
1"-CWR-011171326-101CS1P-N
2"-OLW-011171314-101CS1P-N
SA-JER-DS011-TRJR-480051
2
2
PUMP 011-SP-XXXX(B) 011-TI-XXXX(A) 011-TI-XXXX(B)
CWS LINE No
CWR LINE No
OLW LINE No
P&ID NUMBER
1
1
011-G-0002-A
SP-0651
TI-0656
TI-0657
1"-CWS-011171305-101CS1P-N 1"-CWR-011171305-101CS1P-N 2"-OLW-011171309-101CS1P-N
SA-JER-DS011-TRJR-480015
011-G-0002-B
SP-0653
TI-0676
TI-0677
1"-CWS-011171306-101CS1P-N 1"-CWR-011171306-101CS1P-N
2"-OLW-011171310-101CS1P-N
SA-JER-DS011-TRJR-480015
011-G-0004-A
SP-0701
TI-0706
TI-0707
1"-CWS-011171317-101CS1P-N 1"-CWR-011171317-101CS1P-N
2"-OLW-011171311-101CS1P-N
SA-JER-DS011-TRJR-480021
011-G-0004-B
SP-0703
TI-0726
TI-0727
1"-CWS-011171318-101CS1P-N 1"-CWR-011171318-101CS1P-N 2"-OLW-011171312-101CS1P-N
SA-JER-DS011-TRJR-480021
011-G-0017-A
SP-0751
TI-0756
TI-0757
1"-CWS-011171335-101CS1P-N 1"-CWR-011171335-101CS1P-N 2"-OLW-011171327-101CS1P-N
SA-JER-DS011-TRJR-480101
011-G-0017-B
SP-0753
TI-0776
TI-0777
1"-CWS-011171336-101CS1P-N 1"-CWR-011171336-101CS1P-N 2"-OLW-011171328-101CS1P-N
SA-JER-DS011-TRJR-480101
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS/ MAC
JAL
01
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS/ MAC
JAL
00
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS/ MAC
JAL
PREPARED BY
CHECKED BY
REV
LEGEND 1
CASING VENT
2
PUMP DRAIN
3
BASE PLATE DRAIN
4
FLUSH SEAL CHAMBER INLET (FI)
5
FLUSH SEAL CHAMBER OUTLET (FO)
6
BARRIER / BUFFER FLUID SEAL CHAMBER INLET (LBI)
7
BARRIER / BUFFER FLUID SEAL CHAMBER OUTLET (LBO)
8
GAS BUFFER INLET (GBI)
9
CONTAINMENT SEAL VENT (CSV)
10 CONTAINMENT SEAL DRAIN (CSD) 11 SEAL QUENCH / DRAIN (D) 12 FROM PUMP DISCHARGE 13 TO PUMP SUCTION 14 BEARING HOUSING COOLING INLET. 15 BEARING HOUSING COOLING OUTLET. This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- IF VAPOUR PRESSURE MINOR BUFFER FLUID PRESSURE, ALSO USE LS (H). 2- BARRIER FLUID. FILLING CONNECTION. 3- CONNECTION ON TOP OF PIPE. 4- FOR DRAIN AND VENTS DESTINATION AND DETAILS REFER TO PROCESS DRAWING. 5- NITROGEN QUICK BLADDER ACUMULATOR. 6- RELIEF VALVE SHALL BE ROUTED DIRECTLY TO THE DRAIN PAN.
COMPANY STATUS
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY 011-078 011-074
PIPING AND INSTRUMENT DIAGRAM Project:
011-076 011-075 011-080
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PUMP AUXILIARY SEAL PLAN DETAILS No 2 ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480245.pid
Discipline: PRO
SA-JER-DS011-TRJR-480245 2271-011-PID-0021-171
REV:
03
Sheet: 2 of 11
SCALE: NONE Format:
A1
41
41
40
API PLAN 23/52
40
39
COOLING: K PUMP TYPE: BB2
39
38
38
37
37
36
36
35
35
34
H
PI 33
(B)
PI
XXXX
(D)
TRJR VENDOR
31
PI XXXX
HPT 29
30
RO XXXX
NOTE 2 29
TRJR
28
LFL (A)
PT XXXX
(A)
XXXX
33
TRJR VENDOR
XXXX
32
34
H
PZV XXXX
(A)
(B)
PZV
(A)
32
PT XXXX (B)
PI XXXX (C)
(A)
(B)
VENDOR
29
RO XXXX
30
NOTE 2 29
VENDOR TRJR
NOTE 4
NOTE 4
31
HPT
28
LFL (B)
27
27
26
26
NOTE 1
NOTE 1
25
25
24
TRJR
23
H 22
L
LI XXXX
(A)
LG XXXX
VENDOR
24
LG XXXX (A) TRJR VENDOR
LT XXXX
TI XXXX
(A) D
21
6
19
4 5 14 15
D V
7 1
TRJR
23
7
H
LI (B)
(B)
22
XXXX
L
D
21
(B)
20
18
LT XXXX
TI XXXX
V
(A)
V
VENDOR
(B)
NOTE 3
V 20
6 4 5 14 15
19
D V
18
2
17
3
VENDOR TRJR
16 15
(E)
D VENDOR TRJR 011-SP-XXXX NOTE 3
2"
011-SP-XXXX 011-SP-XXXX
(A)
17
011-SP-XXXX (C)
16
011-SP-XXXX 011-SP-XXXX
(B)
(D)
15
(F)
14
VENDOR
14
TRJR
OLW
13
13
CWS
32
12
12
CWR
11
32
11
10
10
9
9
8
8
7 6
011-RO-XXXX(A) 011-RO-XXXX(B) 011-PZV-XXXX(A) 011-PZV-XXXX(B) 011-LG-XXXX(A)
PUMP
TYPE
011-G-0010-A
BB2
RO-0790
RO-0791
PZV-0790
PZV-0791
LG-0792
011-G-0010-B
BB2
RO-0795
RO-0796
PZV-0795
PZV-0796
LG-0797
011-LG-XXXX(B)
011-LI-XXXX(A)
011-LI-XXXX(B)
011-LT-XXXX(A)
011-LT-XXXX(B)
011-PI-XXXX(A)
011-PI-XXXX(B)
011-PI-XXXX(C)
011-PI-XXXX(D)
011-PT-XXXX(A)
011-PT-XXXX(B)
011-TI-XXXX(A)
011-TI-XXXX(B)
LG-0793
LI-0790
LI-0795
LT-0790
LT-0795
PI-0791
PI-0790
PI-0793
PI-0792
PT-0790
PT-0792
TI-0790
TI-0791
LG-0798
LI-0791
LI-0796
LT-0791
LT-0796
PI-0796
PI-0795
PI-0798
PI-0797
PT-0795
PT-0797
TI-0795
TI-0776
7 6
5
5
011-SP-XXXX(B) 011-SP-XXXX(C) 011-SP-XXXX(D)
011-SP-XXXX(E)
CWS LINE No
011-SP-XXXX(F)
CWR LINE No
LFL LINE No (A)
LFL LINE No (B)
4
PUMP
011-SP-XXXX(A)
3
011-G-0010-A
SP-0790
SP-0791
SP-0792
SP-0793
SP-0794-A
SP-0794-B
2"-CWS-011171323-101CS1P-N
2"-CWR-011171323-101CS1P-N
3/4"-LFL-011171305-101CH2F-N
3/4"-LFL-011171315-101CH2F-N
011-G-0010-B
SP-0795
SP-0796
SP-0797
SP-0798
SP-0799-A
SP-0799-B
2"-CWS-011171324-101CS1P-N
2"-CWR-011171324-101CS1P-N
3/4"-LFL-011171306-101CH2F-N
3/4"-LFL-011171316-101CH2F-N
OLW LINE No
P&ID NUMBER
4
2"-OLW-011171315-101CS1P-N
SA-JER-DS011-TRJR-480064
3
2"-OLW-011171316-101CS1P-N
SA-JER-DS011-TRJR-480064
2
2
1
1
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS/ HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS/ MAC
JAL
01
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS/ MAC
JAL
00
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS/ MAC
JAL
PREPARED BY
CHECKED BY
REV
LEGEND
GENERAL NOTES
1
CASING VENT
2
PUMP DRAIN
3
BASE PLATE DRAIN
4
FLUSH SEAL CHAMBER INLET (FI)
5
FLUSH SEAL CHAMBER OUTLET (FO)
6
BARRIER / BUFFER FLUID SEAL CHAMBER INLET (LBI)
1- BARRIER FLUID. FILLING CONNECTION. 2- MAKE CONNECTION ON TOP OF PIPE. 3- FOR DRAIN AND VENT DESTINATION AND DETAILS REFER TO PROCESS DRAWING.
7
BARRIER / BUFFER FLUID SEAL CHAMBER OUTLET (LBO)
4- RELIEF VALVE SHALL BE ROUTED TO DRAIN PAN.
8
GAS BUFFER INLET (GBI)
9
CONTAINMENT SEAL VENT (CSV)
10 CONTAINMENT SEAL DRAIN (CSD) 11 SEAL QUENCH / DRAIN (D) 12 FROM PUMP DISCHARGE 13 TO PUMP SUCTION 14 BEARING HOUSING COOLING INLET. 15 BEARING HOUSING COOLING OUTLET. This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY 011-078 011-074
PIPING AND INSTRUMENT DIAGRAM Project:
011-076 011-075 011-080
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PUMP AUXILIARY SEAL PLAN DETAILS No 3 ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480246.pid
Discipline: PRO
SA-JER-DS011-TRJR-480246 2271-011-PID-0021-171
REV:
03
Sheet: 3 of 11
SCALE: NONE Format:
A1
41
41
40
40
39
API PLAN 21/53 B
API PLAN 21/52
COOLING: K PUMP TYPE: BB2
COOLING: K PUMP TYPE: OH2
38 37
NOTE 1
39 38 37
NOTE 1
36
36
35
35
PI
34
L
PI
XXXX (D)
33
(B)
PT XXXX
31
PI
L
PI XXXX
(B)
(C)
PZV XXXX
PZV XXXX
(B)
(A)
(A)
PI XXXX
(A)
34
H
(B) XXXX
TRJR VENDOR
TRJR VENDOR
32
XXXX
33
TRJR VENDOR
PT XXXX
32
PT XXXX
PZV XXXX
PI XXXX
(A)
29
RO XXXX
30
NOTE 5
NOTE 5
31
HPT
29
NOTE 3 (A) VENDOR
NOTE 5
30 29
TRJR
NOTE 2
NOTE 2 28
28
LFL (B) D
D
27
27
TI XXXX
TI XXXX
26
NOTE 2
(C)
(D)
25
26 25
24
24
LG XXXX
23
D RO XXXX
1/2" NPT
22
(B) 21
NOTE 4 TRJR VENDOR
V TI XXXX
V
RO XXXX
TI XXXX
V (B) 5
1
6
6
12 4 8
19
D
9
1/2" NPT
7 5 12 4 8 9 3
(D)
14
011-SP-XXXX 011-SP-XXXX (B)
32
22
L
(F)
VENDOR TRJR
VENDOR TRJR
VENDOR TRJR
RO XXXX D
011-SP-XXXX
011-SP-XXXX
VENDOR TRJR NOTE 4
17 16
011-SP-XXXX
VENDOR TRJR NOTE 4
(C)
(A)
(E)
18
1/2" NPT
(B)
3
011-SP-XXXX
19
D
2
011-SP-XXXX 011-SP-XXXX
(A)
(C)
15
(B) VENDOR
14
TRJR
OLW
OLW
13
XXXX
H
20
VENDOR
TRJR
LI
6
D
D
15
23
21
4 12 14 15
1/2" NPT
17
011-SP-XXXX
LT XXXX
TI XXXX
(A)
2
1/2" NPT
16
TRJR
(A)
20
18
VENDOR
D
CWS
CWS
13
32
12 11
12
32
CWR
CWR
32
11
10
10
9
9
8
8
7 6 5 4 3 2 1
011-SP-XXXX(A)
011-SP-XXXX(B) 011-SP-XXXX(C) 011-SP-XXXX(D)
011-SP-XXXX(E)
011-SP-XXXX(F)
011-PI-XXXX(A)
011-PI-XXXX(B)
011-PI-XXXX(C)
011-PI-XXXX(D)
PUMP
SP-0899
SP-0893
SP-0898
PI-0890
PI-0891
PI-0892
PI-0893
011-G-0016-A
OH2
RO-0960
RO-0961
SP-0904
SP-0909
SP-0903
SP-0908
PI-0900
PI-0901
PI-0902
PI-0903
011-G-0016-B
OH2
RO-0965
RO-0966
SP-0935
SP-0932
SP-0937
SP-0933
SP-0939
PI-0930
PI-0931
PI-0932
PI-0933
SP-0945
SP-0942
SP-0947
SP-0943
SP-0949
PI-0940
PI-0941
PI-0942
PI-0943
PUMP
TYPE
011-G-0014-A
BB2
SP-0890
SP-0895
SP-0894
011-G-0014-B
BB2
SP-0900
SP-0905
011-G-0018-A
BB2
SP-0930
011-G-0018-B
BB2
SP-0940
011-PT-XXXX-B
011-PZV-XXXX(A) 011-PZV-XXXX(B) 011-TI-XXXX(A)
011-TI-XXXX(C)
011-TI-XXXX(D)
TI-0893
TI-0894
TI-0895
TI-0896
RO-0890
RO-0891
PZV-0901
TI-0903
TI-0904
TI-0905
TI-0906
RO-0900
RO-0901
PZV-0930
PZV-0931
TI-0933
TI-0934
TI-0935
TI-0936
RO-0930
RO-0931
PZV-0940
PZV-0941
TI-0943
TI-0944
TI-0945
TI-0946
RO-0940
RO-0941
011-PT-XXXX(A)
011-G-0014-A
PT-0891
PT-0893
PZV-0890
PZV-0891
011-G-0014-B
PT-0901
PT-0903
PZV-0900
011-G-0018-A
PT-0931
PT-0933
011-G-0018-B
PT-0941
PT-0943
CWS LINE No
PUMP
011-RO-XXXX(A) 011-RO-XXXX(B)
011-TI-XXXX(B)
PUMP
CWR LINE No
OLW LINE No
TYPE 011-RO-XXXX(A) 011-RO-XXXX(B) 011-LG-XXXX
011-LT-XXXX
LG-0960
LI-0961
LT-0961
PI-0960
LG-0965
LI-0966
LT-0966
PI-0965
2"-CWS-011171329-101CS1P-N
2"-CWR-011171329-101CS1P-N
2"-OLW-011171319-101CS1P-N
SA-JER-DS011-TRJR-480066
011-G-0014-B
2"-CWS-011171330-101CS1P-N
2"-CWR-011171330-101CS1P-N
2"-OLW-011171320-101CS1P-N
011-G-0018-A
2"-CWS-011171333-101CS1P-N
2"-CWR-011171333-101CS1P-N
011-G-0018-B
2"-CWS-011171334-101CS1P-N
2"-CWR-011171334-101CS1P-N
CASING VENT
2
PUMP DRAIN
3
BASE PLATE DRAIN
4
FLUSH SEAL CHAMBER INLET (FI)
5
FLUSH SEAL CHAMBER OUTLET (FO)
6
BARRIER / BUFFER FLUID SEAL CHAMBER INLET (LBI)
7
BARRIER / BUFFER FLUID SEAL CHAMBER OUTLET (LBO)
8
GAS BUFFER INLET (GBI)
9
CONTAINMENT SEAL VENT (CSV)
PUMP
011-PZV-XXXX
011-SP-XXXX(A)
011-SP-XXXX(B)
011-SP-XXXX(C)
CWS LINE No
CWR LINE No
7 6
LFL LINE No (B)
4 3
3/4"-LFL-011171331-101CH2F-N
011-G-0016-B
PZV-0965
SP-0965
SP-0967
SP-0969
1"-CWS-011171338-101CS1P-N 1"-CWR-011171338-101CS1P-N
3/4"-LFL-011171332-101CH2F-N 2
PUMP
OLW LINE No
1
P&ID NUMBER
011-G-0016-A
2"-OLW-011171321-101CS1P-N
SA-JER-DS011-TRJR-480099
011-G-0016-B
2"-OLW-011171322-101CS1P-N
SA-JER-DS011-TRJR-480099
02
30-SEP-2011
01
2"-OLW-011171335-101CS1P-N
SA-JER-DS011-TRJR-480103
00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
TI-0966
1"-CWS-011171337-101CS1P-N 1"-CWR-011171337-101CS1P-N
SA-JER-DS011-TRJR-480103
15 BEARING HOUSING COOLING OUTLET.
PT-0966
SP-0964
2"-OLW-011171334-101CS1P-N
14 BEARING HOUSING COOLING INLET.
PI-0966
SP-0962
SA-JER-DS011-TRJR-480066
13 TO PUMP SUCTION
TI-0961
SP-0960
AB
12 FROM PUMP DISCHARGE
PT-0961
PZV-0960
13-MAR-2013
11 SEAL QUENCH / DRAIN (D)
PI-0961
011-G-0016-A
03
10 CONTAINMENT SEAL DRAIN (CSD)
011-TI-XXXX
5
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS/ MAC
JAL
13-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS/ MAC
JAL
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS/ MAC
JAL
PREPARED BY
CHECKED BY
REV
1
011-PT-XXXX
P&ID NUMBER
011-G-0014-A
LEGEND
011-PI-XXXX(A) 011-PI-XXXX(B)
011-LI-XXXX
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- NITROGEN QUICK BLADDER ACUMULATOR. 2- BARRIER FLUID FILLING CONNECTION. 3- MAKE CONNECTION ON TOP OF PIPE. 4- FOR DRAIN AND VENT DESTINATION AND DETAILS REFER TO PROCESS DRAWING. 5- RELIEF VALVE SHALL BE ROUTED TO DRAIN PAN.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY 011-078 011-074
PIPING AND INSTRUMENT DIAGRAM Project:
011-076 011-075 011-080
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PUMP AUXILIARY SEAL PLAN DETAILS No 4 ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480247.pid
Discipline: PRO
SA-JER-DS011-TRJR-480247 2271-011-PID-0021-171
REV:
03
Sheet: 4 of 11
SCALE: NONE Format:
A1
41
41
40
40
39 38
API PLAN 11/53B
API PLAN 11/61
COOLING: M PUMP TYPE: OH2
COOLING: NONE PUMP TYPE: OH2
39 38
37
37
36
36
35
35
NOTE 1
34
34
33
33
32
32
PI (B) XXXX L
31
31
TRJR VENDOR
30
PI XXXX
PZV XXXX
29
30
NOTE 5 CL600RF
PT XXXX
29
3/4"
(A)
28
28
NOTE 6
27
27
NOTE 3
26
D 3/4"
25
TRJR VENDOR
RO XXXX
V
TI XXXX
24
26 25
NOTE 4
1
24
12 23
23
4 22
22
2
D
21
V
NPT
WATER FROM 011-G-0022 DS011-TRJR-480124
20
RO XXXX
19
VENDOR TRJR
21
3
20
D
NOTE 3
VENDOR TRJR
19
011-SP-XXXX
18 17
18 17
12
16
VENDOR
TRJR
OLW 16
4 3/4"
2
15 14
VENDOR TRJR
HYDROCARBONS FROM 011-G-0020 DS011-TRJR-480087
13
CWS
32
CWR
32
15
3 3/4"
D
14 13
VENDOR TRJR NOTE 3
12
12
11
11
OLW
10
10
9
9
8
8
7
7
PUMP
TYPE
011-RO-XXXX
011-PI-XXXX-A
011-PI-XXXX-B
011-PT-XXXX
011-PZV-XXXX
011-SP-XXXX
011-TI-XXXX
OLW LINE No
PUMP
TYPE
011-RO-XXXX
OH2
RO-0980
2"-OLW-011171326-101CS1P-N
SA-JER-DS011-TRJR-480124
OH2
RO-0985
2"-OLW-011171325-101CS1P-N
SA-JER-DS011-TRJR-480124
P&ID NUMBER
6
6
5
011-G-0020-A
OH2
RO-0970
PI-0970
PI-0971
PT-0971
PZV-0970
SP-0970
TI-0971
011-G-0022-A
011-G-0020-B
OH2
RO-0975
PI-0975
PI-0976
PT-0976
PZV-0975
SP-0975
TI-0976
011-G-0022-B
5
4
4
PUMP
3 2
CWS LINE No
CWR LINE No
OLW LINE No
P&ID NUMBER
011-G-0020-A
3/4"-CWS-011171341-101CS1P-N 3/4"-CWR-011171341-101CS1P-N 2"-OLW-011171323-101CS1P-N
SA-JER-DS011-TRJR-480087
011-G-0020-B
3/4"-CWS-011171342-101CS1P-N 3/4"-CWR-011171342-101CS1P-N 2"-OLW-011171324-101CS1P-N
SA-JER-DS011-TRJR-480087
3 2
1
1
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
01
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS / MAC
JAL
00
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
PREPARED BY
CHECKED BY
REV
LEGEND 1
CASING VENT
2
PUMP DRAIN
3
BASE PLATE DRAIN
4
FLUSH SEAL CHAMBER INLET (FI)
5
FLUSH SEAL CHAMBER OUTLET (FO)
6
BARRIER / BUFFER FLUID SEAL CHAMBER INLET (LBI)
7
BARRIER / BUFFER FLUID SEAL CHAMBER OUTLET (LBO)
8
GAS BUFFER INLET (GBI)
9
CONTAINMENT SEAL VENT (CSV)
10 CONTAINMENT SEAL DRAIN (CSD) 11 SEAL QUENCH / DRAIN (D) 12 FROM PUMP DISCHARGE 13 TO PUMP SUCTION 14 BEARING HOUSING COOLING INLET. 15 BEARING HOUSING COOLING OUTLET. This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- NITROGEN QUICK BLADDER ACUMULATOR. 2- MAKE CONNECTION ON TOP OF PIPE. 3- FOR DRAIN AND VENT RESTINATION AND DETAILS REFER TO PROCESS DRAWING. 4- NOT APPLY TO PUMP 011-G-0022A/B. 5- BARRIER FLUID. FILLING CONNECTION. 6- RELIEF VALVE SHALL BE ROUTED TO DRAIN-PAN.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM
011-078 Project:
011-074
011-076 011-075 011-080
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PUMP AUXILIARY SEAL PLAN DETAILS No 5 ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480248.pid
Discipline: PRO
SA-JER-DS011-TRJR-480248 2271-011-PID-0021-171
REV:
03
Sheet: 5 of 11
SCALE: NONE Format:
A1
41
41
40
40
39 38
API PLAN 13/53B
API PLAN 53B
COOLING: M PUMP TYPE: VS1
COOLING: K PUMP TYPE: OH2
39 38
37
37
NOTE 2 36
36
NOTE 2
35
35
PI
34
(B) XXXX
PI
33
(B) XXXX 32
TRJR
31
VENDOR
0.2%
L
30
33
PT XXXX
PI XXXX
PZV XXXX
PT XXXX
PI XXXX (A)
L
TRJR VENDOR
TRJR VENDOR
PZV XXXX
34
32
NOTE 3 CL600RF
3/4"
31
(A)
30
29
29
NOTE 5 3/4"
28
NOTE 3
OLW
27
VENDOR TRJR
25
28 27
TI XXXX
D
M
26
CL600RF
D
26
TRJR VENDOR
25
24
24
LBL (A)
6
23
23
D NPT 3/4"
LBL (B)
7
RO XXXX
22
V
22
V
21
21
011-SP-XXXX 13
20
011-SP-XXXX
7 1 14
20
(A)
(B) 6
19
19
15 VENDOR
TRJR
18
18
VENDOR TRJR
17
32 17
3
VENDOR TRJR
011-SP-XXXX
16
CWS
2
CWR
D
16
32
2"
15
15
VENDOR TRJR NOTE 1
14 13
CWS
13
32
OLW
12
CWR
11
14
12
32
11
10
10
9
9
8
8
7
7
PUMP
TYPE
011-RO-XXXX
011-PZV-XXXX
011-PI-XXXX(A)
011-G-0025-A
VS1
RO-0640
PZV-0640
PI-0641
011-PI-XXXX(B)
011-PT-XXXX
011-SP-XXXX
011-TI-XXXX
PUMP
TYPE
011-PZV-XXXX
011PT-XXXX
PT-0640
SP-0640
N/A
011-G-0026-A
OH2
PZV-0990
PT-0991
011-G-0026-B
OH2
PZV-0995
PT-0996
011-PI-XXXX(A)
011-PI-XXXX(B)
011-SP-XXXX(A)
011-SP-XXXX(B)
011-TI-XXXX
PI-0990
PI-0991
SP-0990
SP-0992
TI-0991
PI-0995
PI-0996
SP-0995
SP-0997
TI-0996
6
6
PI-0640
5
PUMP
4
011-G-0025-A
3
CWS LINE No
CWR LINE No
3/4"-CWS-011171313-101CS1P-N 3/4"-CWR-011171313-101CS1P-N
LUB LINE (A)
LUB LINE (B)
3/4"-LUB-011171401-106SU0P-N
3/4"-LUB-011171402-106SU0P-N
OLW LINE No 2"-OLW-011171346-101CS1P-N
5
P&ID NUMBER SA-JER-DS011-TRJR-480232
2
4
PUMP
CWS LINE No
CWR LINE No
OLW LINE No
P&ID NUMBER
3
011-G-0026-A
3/4"-CWS-011171301-101CS1P-N 3/4"-CWR-011171301-101CS1P-N 2"-OLW-011171329-101CS1P-N
SA-JER-DS011-TRJR-480219
011-G-0026-B
3/4"-CWS-011171302-101CS1P-N 3/4"-CWR-011171302-101CS1P-N 2"-OLW-011171330-101CS1P-N
SA-JER-DS011-TRJR-480219
2
1
1
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
01
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
00
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
PREPARED BY
CHECKED BY
REV
LEGEND 1
CASING VENT
2
PUMP DRAIN
3
BASE PLATE DRAIN
4
FLUSH SEAL CHAMBER INLET (FI)
5
FLUSH SEAL CHAMBER OUTLET (FO)
6
BARRIER / BUFFER FLUID SEAL CHAMBER INLET (LBI)
7
BARRIER / BUFFER FLUID SEAL CHAMBER OUTLET (LBO)
8
GAS BUFFER INLET (GBI)
9
CONTAINMENT SEAL VENT (CSV)
10 CONTAINMENT SEAL DRAIN (CSD) 11 SEAL QUENCH / DRAIN (D) 12 FROM PUMP DISCHARGE 13 TO PUMP SUCTION 14 BEARING HOUSING COOLING INLET. 15 BEARING HOUSING COOLING OUTLET. This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- FOR DRAIN AND VENT DESTINATION AND DETAILS REFER TO PROCESS DRAWING. 2- NITROGEN QUICK BLADDER ACUMULATOR. 3- BARRIER FLUID. FILLING CONNECTION. 4- MAKE CONNECTION ON TOP OF PIPE. 5- RELIEF VALVE SHOULD BE ROUTED TO DRAIN PAN.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY 011-078 011-074
PIPING AND INSTRUMENT DIAGRAM Project:
011-076 011-075 011-080
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PUMP AUXILIARY SEAL PLAN DETAILS No 6 ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480249.pid
Discipline: PRO
SA-JER-DS011-TRJR-480249 2271-011-PID-0021-171
REV:
03
Sheet: 6 of 11
SCALE: NONE Format:
A1
41
41
40
40
39
API PLAN 23/52
API PLAN 23/61
COOLING: K PUMP TYPE: OH2
COOLING: M PUMP TYPE: OH2
38
39 38
37
37
36
36
35
35
34
34
33
33
PI
32
H 32
(B) XXXX 31
31
TRJR VENDOR
30
PT XXXX
PZV XXXX
29
30
PI XXXX
HPT
(A)
28
28
NOTE 2 VENDOR
NOTE 3
29
29
RO XXXX TRJR
27
27
26
LFL (B)
26
NOTE 5
25
NOTE 5
TI XXXX
V
25
D
24
24
4 NOTE 4
23
LG XXXX
22 21 20
V
VENDOR
22
V
TRJR
LT XXXX
TI XXXX
LI XXXX
V
2
D
H
NOTE 5
1 7
4 5 14 15
18 17
VENDOR TRJR NOTE 1
15 14
TRJR
19
VENDOR
V
17
OLW D
2" VENDOR TRJR NOTE 1
011-SP-XXXX
32
CWS
32
CWR
16
011-SP-XXXX
15 14
011-SP-XXXX (A)
(B)
13
(C)
13
VENDOR 12
20
3
VENDOR TRJR
HYDROCARBON FROM 011-G-0011A/B DS011-TRJR-480055
011-SP-XXXX
2"
WATER FROM 011-G-0024/28 DS011-TRJR 480013(011-G-0024A/B) 480201(011-G-0028A/B)
18
2
16
VENDOR TRJR
L
D
6
21
3
NOTE 5
(A)
19
23
5
TRJR 12
OLW
11 10
CWS
32
CWR
32
11 10
9
9
8
8
7
7
6
6
5 4 3 2
011-RO-XXXX
011-SP-XXXX(A)
011-SP-XXXX(B)
011-SP-XXXX(C)
011-LI-XXXX
011-LG-XXXX
011-LT-XXXX
011-PI-XXXX(A)
PUMP
TYPE
011-G-0011-A
OH2
RO-0510
SP-0510
SP-0512
SP-0514
LI-0510
LG-0511
LT-0510
PI-0510
011-G-0011-B
OH2
RO-0515
SP-0515
SP-0517
SP-0519
LI-0515
LG-0516
LT-0515
011-G-0013-A
OH2
RO-0520
SP-0520
SP-0522
SP-0524
LI-0520
LG-0521
011-G-0013-B
OH2
RO-0525
SP-0525
SP-0527
SP-0529
LI-0525
LG-0526
011-PI-XXXX(B)
CWR LINE No
SP-0590
3/4"-CWS-011171309-101CS1P-N
3/4"-CWR-011171307-101CS1P-N
2"-OLW-011171332-101CS1P-N
SA-JER-DS011-TRJR-480201
TI-0595
SP-0595
3/4"-CWS-011171307-101CS1P-N
3/4"-CWR-011171308-101CS1P-N
2"-OLW-011171333-101CS1P-N
SA-JER-DS011-TRJR-480201
OH2
TI-0404
SP-0540
3/4"-CWS-011171399-101CS1P-N
3/4"-CWR-011171309-101CS1P-N
2"-OLW-011171347-101CS1P-N
SA-JER-DS011-TRJR-480013
OH2
TI-0405
SP-0545
3/4"-CWS-011171310-101CS1P-N
3/4"-CWR-011171310-101CS1P-N
2"-OLW-011171348-101CS1P-N
SA-JER-DS011-TRJR-480013
TYPE
PI-0511
011-G-0028-A
OH2
TI-0590
PI-0515
PI-0516
011-G-0028-B
OH2
LT-0520
PI-0520
PI-0521
011-G-0024-A
LT-0525
PI-0525
PI-0526
011-G-0024-B
011-SP-XXXX
OLW LINE No
5
CWS LINE No
011-TI-XXXX
PUMP
P&ID NUMBER
4 3 2
1
1
PUMP
011-PT-XXXX
011-PZV-XXXX
011-TI-XXXX
CWS LINE No
CWR LINE No
LFL LINE No (B)
OLW LINE No
P&ID NUMBER
3/4"-LFL-011171354-101CH2F-N
2"-OLW-011171301-101CS1P-N
SA-JER-DS011-TRJR-480055
011-G-0011-A
PT-0511
PZV-0510
TI-0510
1-1/2"-CWS-011171345-101CS1P-N
1-1/2"-CWR-011171345-101CS1P-N
011-G-0011-B
PT-0516
PZV-0515
TI-0515
1-1/2"-CWS-011171346-101CS1P-N
1-1/2"-CWR-011171346-101CS1P-N
3/4"-LFL-011171355-101CH2F-N
2"-OLW-011171302-101CS1P-N
SA-JER-DS011-TRJR-480055
011-G-0013-A
PT-0521
PZV-0520
TI-0520
1-1/2"-CWS-011171331-101CS1P-N
1-1/2"-CWR-011171331-101CS1P-N
3/4"-LFL-011171356-101CH2F-N
2"-OLW-011171303-101CS1P-N
SA-JER-DS011-TRJR-480057
011-G-0013-B
PT-0526
PZV-0525
TI-0525
1-1/2"-CWS-011171332-101CS1P-N
1-1/2"-CWR-011171332-101CS1P-N
3/4"-LFL-011171357-101CH2F-N
2"-OLW-011171304-101CS1P-N
SA-JER-DS011-TRJR-480057
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS/ MAC
JAL
01
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS/ MAC
JAL
00
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS/ MAC
JAL
PREPARED BY
CHECKED BY
REV
LEGEND
GENERAL NOTES
1
CASING VENT
2
PUMP DRAIN
3
BASE PLATE DRAIN
4
FLUSH SEAL CHAMBER INLET (FI)
5
FLUSH SEAL CHAMBER OUTLET (FO)
6
BARRIER / BUFFER FLUID SEAL CHAMBER INLET (LBI)
7
BARRIER / BUFFER FLUID SEAL CHAMBER OUTLET (LBO)
1- FOR DRAIN AND VENT DESTINATION AND DETAILS REFER TO PROCESS DRAWING. 2- MAKE CONNECTION ON TOP OF PIPE. 3- RELIEF VALVE SHALL BE ROUTED TO DRAIN PAN. 4- FOR ITEM 011-G-0024. ADDITIONAL VENT AND DRAIN PLUGGED ARE INCLUDED IN THE HEAT EXCHANGER.
8
GAS BUFFER INLET (GBI)
5- NOT APPLY FOR ITEM 011-G-0024.
9
CONTAINMENT SEAL VENT (CSV)
10 CONTAINMENT SEAL DRAIN (CSD) 11 SEAL QUENCH / DRAIN (D) 12 FROM PUMP DISCHARGE 13 TO PUMP SUCTION 14 BEARING HOUSING COOLING INLET. 15 BEARING HOUSING COOLING OUTLET. This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS. DESCRIPTION 011-073 19 N.A. 011-072 20 FUEL OIL 011-073 21 FUEL GAS 011-071 22 N.A. 23 N.A. 24 N.A. 25 CLOSED DRAIN 26 N.A. 011-071 27 L.P. NITROGEN 011-071 28 H.P. FLARE 29 L.P. FLARE 011-071 30 SOUR/ACID FLARE 011-071 31 PILOT GAS 011-071 32 AUX COOLING WATER 011-074 011-074
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY 011-078 011-074
PIPING AND INSTRUMENT DIAGRAM Project:
011-076 011-075 011-080
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PUMP AUXILIARY SEAL PLAN DETAILS No 7 ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480250.pid
Discipline: PRO
SA-JER-DS011-TRJR-480250 2271-011-PID-0021-171
REV:
03
Sheet: 7 of 11
SCALE: NONE Format:
A1
41
41
40
40
39
API PLAN 21/76/72
API PLAN 53B
COOLING: PUMP TYPE: OH2
COOLING: M PUMP TYPE: OH2
38
39 38
37
37
36
36
35
35
NOTE 2
34
34
33
33
PI
32
(B) 31
(B) XXXX
L
PI XXXX
PT XXXX (A)
28 27 26
TRJR
29
25
NOTE 4
31
NOTE 3 CL600RF
30
3/4"
29
(A)
28
(A)
NOTE 5 27
FG XXXX
HPT
L
PT XXXX
PI XXXX
PZV XXXX
TRJR VENDOR
29
XXXX
TRJR VENDOR
PI 30
32
PCV XXXX
VENDOR
26
TRJR
VENDOR
3/4" D
CL 600 N2L
LFL (A)
CL 600 600 RF
3/4" V
1/2"
24
25
NPT
27
24
VENDOR TRJR
3/4"X1/2" V
23
PI XXXX (C)
RO XXXX
22
PT XXXX
23
H
PI XXXX (D)
(B)
(C)
22
V
21 20
TI XXXX
D
8
19
1 4
17
20
V
(A)
D
D 9 10
18
NPT
RO XXXX
19
21
3/4" D
6
18
011-SP-XXXX
7
12
17
VENDOR TRJR
16
16
V
15
3
3
VENDOR TRJR
14 13
32 15
VENDOR TRJR
CWR
D
011-SP-XXXX
D VENDOR TRJR NOTE 1
2"
14
32
2" VENDOR
CWS OLW
13
VENDOR TRJR NOTE 1
TRJR
12 11
CWS
2
D
2
12
32
11
OLW
10
CWR
10
32
9
9
8
8
7
7
6
6
4
011-PCV-XXXX
011-PT-XXXX(A)
011-PT-XXXX(B)
RO-0691
PCV-0690
PT-0690
PT-0692
RO-0696
PCV-0695
PT-0695
PT-0697
011-RO-XXXX(A) 011-RO-XXXX(B)
PUMP
TYPE
011-G-0003-A
OH2
RO-0690
011-G-0003-B
OH2
RO-0695
5
PUMP 011-G-0027
3
PUMP 011-PI-XXXX(A)
2
PUMP
1
011-G-0003-A
PI-0691
011-G-0003-B
PI-0696
011-TI-XXXX
011-PI-XXXX(C)
011-PI-XXXX(D)
011-SP-XXXX
PI-0690
PI-0693
PI-0692
SP-0690
TI-0690
PI-0695
PI-0698
PI-0697
SP-0695
TI-0695
011-PI-XXXX(B)
CWR LINE No
PUMP
CWS LINE No
011-G-0003-A
3/4"-CWS-011171315-101CS1P-N
3/4"-CWR-011171315-101CS1P-N
011-G-0003-B
3/4"-CWS-011171316-101CS1P-N
3/4"-CWR-011171316-101CS1P-N
OLW LINE No
011-G-0027
TYPE
011-PZV-XXXX
011-PI-XXXX(A)
011-PI-XXXX(B)
011-PT-XXXX
011-SP-XXXX
OH2
PZV-0580
PI-0580
PI-0581
PT-0581
SP-0580
CWS LINE No
CWR LINE No
1
CASING VENT
2
PUMP DRAIN
3
BASE PLATE DRAIN
4
FLUSH SEAL CHAMBER INLET (FI)
5
FLUSH SEAL CHAMBER OUTLET (FO)
6
BARRIER / BUFFER FLUID SEAL CHAMBER INLET (LBI)
7
BARRIER / BUFFER FLUID SEAL CHAMBER OUTLET (LBO)
8
GAS BUFFER INLET (GBI)
9
CONTAINMENT SEAL VENT (CSV)
10 CONTAINMENT SEAL DRAIN (CSD) 11 SEAL QUENCH / DRAIN (D) 12 FROM PUMP DISCHARGE 13 TO PUMP SUCTION 14 BEARING HOUSING COOLING INLET. 15 BEARING HOUSING COOLING OUTLET. This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
4 3
P&ID NUMBER
OLW LINE No
2
SA-JER-DS011-TRJR-480233
3/4"-CWS-011171398-101CS1P-N 3/4"-CWR-011171398-101CS1P-N 2"-OLW-011171331-101CS1P-N
1
P&ID NUMBER
N2L LINE No
LFL LINE No
2"-OLW-011171336-101CS1P-N
1/2"-N2L-011171301-101CS1P-N
3/4"-LFL-011171365-101CH2F-N
SA-JER-DS011-TRJR-480022
2"-OLW-011171337-101CS1P-N
1/2"-N2L-011171302-101CS1P-N
3/4"-LFL-011171366-101CH2F-N
SA-JER-DS011-TRJR-480022
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
01
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
00
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
REV
LEGEND
5
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- FOR DRAIN AND VENT DESTINATION AND DETAILS REFER TO PROCESS DRAWING. 2- NITROGEN QUICK BLADDER ACUMULATOR. 3- BARRIER FLUID. FILLING CONNECTION. 4- MAKE CONNECTION ON TOP OF PIPE. 5- RELIEF VALVE SHALL BE ROUTED TO DRAIN PAN.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY 011-078 011-074
PIPING AND INSTRUMENT DIAGRAM Project:
011-076 011-075 011-080
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PUMP AUXILIARY SEAL PLAN DETAILS No 8 ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480251.pid
Discipline: PRO
SA-JER-DS011-TRJR-480251 2271-011-PID-0021-171
REV:
03
Sheet: 8 of 11
SCALE: NONE Format:
A1
41
41
40
40
39
API PLAN 23/65
API PLAN 23/65
COOLING: K PUMP TYPE: BB2
COOLING: K PUMP TYPE: 0H2
38
39 38
37
37
36
36
35
35
34
34
33
33
32
32
31
31
30
30
29
TI XXXX
TI XXXX
V
(B)
(A)
28
29
TI XXXX
28
27
27
V
26
LI XXXX (A)
24 23
H
V
(B)
TRJR VENDOR
NOTE 1
LT XXXX
22
5
20
11 14 15
19
4
1
(A)
15
22
2
(C)
NOTE 1
11 14 15
11 4
20 19
2 VENDOR TRJR
(B)
3/4" CL600 011-SP-XXXX
011-SP-XXXX
VENDOR TRJR 2"
RO XXXX
NOTE 1
(D)
VENDOR TRJR
3
011-SP-XXXX (B)
D VENDOR TRJR NOTE 1
18
RO XXXX
17
3/4" 011-SP-XXXX
(B)
VENDOR TRJR
011-SP-XXXX
16
(A) VENDOR
VENDOR
TRJR
OLW
14
21
5
5
D 2" VENDOR TRJR NOTE 1
3/4" CL600
VENDOR TRJR
011-SP-XXXX (A)
23
LT XXXX 1
4
3 RO XXXX
16
24
(B)
21
17
25
D
TRJR VENDOR
LT XXXX
V
H
LI XXXX
V
TRJR VENDOR
TRJR
(A)
18
D
LI XXXX
V
CLD
D
25
26
OLW
25
CWS
32
15
TRJR
14
CWS
32
13
13
CWR
32
12
CWR
12
32
11
11
10
10
9
9
8
8
7
7
PUMP
TYPE
011-RO-XXXX(A) 011-RO-XXXX(B)
011-LI-XXXX(A)
011-LI-XXXX(B)
011-LT-XXXX(A)
011-LT-XXXX(B)
011-TI-XXXX(A)
011-TI-XXXX(B)
PUMP
TYPE
011-RO-XXXX
011-LI-XXXX
011-LT-XXXX
011-TI-XXXX
011-SP-XXXX(A)
011-SP-XXXX(B)
6
6
5
011-G-0008-A
BB2
RO-0851
RO-0852
LI-0851
LI-0853
LT-0851
LT-0853
TI-0853
TI-0854
011-G-0009-A
BB2
RO-0740
LI-0740
LT-0740
TI-0740
SP-0740
SP-0742
011-G-0008-B
BB2
RO-0861
RO-0862
LI-0861
LI-0863
LT-0861
LT-0863
TI-0863
TI-0864
011-G-0009-B
BB2
RO-0745
LI-0745
LT-0745
TI-0745
SP-0745
SP-0747
5
4 3 2
4
011-SP-XXXX(B) 011-SP-XXXX(C)
011-SP-XXXX(D)
CWS LINE No
CWR LINE No
PUMP
011-SP-XXXX(A)
011-G-0008-A
SP-0851
SP-0852
SP-0850
SP-0853
1-1/2"-CWS-011171319-101CS1P-N
011-G-0008-B
SP-0861
SP-0862
SP-0860
SP-0863
1-1/2"-CWS-011171320-101CS1P-N
OLW LINE No
P&ID NUMBER
PUMP
CWS LINE No
CWR LINE No
OLW LINE No
P&ID NUMBER
1-1/2"-CWR-011171319-101CS1P-N
2"-OLW-011171338-101CS1P-N
SA-JER-DS011-TRJR-480063
011-G-0009-A
1-1/2"-CWS-011171343-101CS1P-N
1-1/2"-CWR-011171343-101CS1P-N
2"-OLW-011171339-101CS1P-N
SA-JER-DS011-TRJR-480053
1-1/2"-CWR-011171320-101CS1P-N
2"-OLW-011171345-101CS1P-N
SA-JER-DS011-TRJR-480063
011-G-0009-B
1-1/2"-CWS-011171344-101CS1P-N
1-1/2"-CWR-011171344-101CS1P-N
2"-OLW-011171340-101CS1P-N
SA-JER-DS011-TRJR-480053
3 2
1
1
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS/ MAC
JAL
01
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS/ MAC
JAL
00
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS/ MAC
JAL
PREPARED BY
CHECKED BY
REV
LEGEND 1
CASING VENT
2
PUMP DRAIN
3
BASE PLATE DRAIN
4
FLUSH SEAL CHAMBER INLET (FI)
5
FLUSH SEAL CHAMBER OUTLET (FO)
6
BARRIER / BUFFER FLUID SEAL CHAMBER INLET (LBI)
7
BARRIER / BUFFER FLUID SEAL CHAMBER OUTLET (LBO)
8
GAS BUFFER INLET (GBI)
9
CONTAINMENT SEAL VENT (CSV)
10 CONTAINMENT SEAL DRAIN (CSD) 11 SEAL QUENCH / DRAIN (D) 12 FROM PUMP DISCHARGE 13 TO PUMP SUCTION 14 BEARING HOUSING COOLING INLET. 15 BEARING HOUSING COOLING OUTLET. This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- FOR DRAIN AND VENT DESTINATION AND DETAILS REFER TO PROCESS DRAWING.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY 011-078 011-074
PIPING AND INSTRUMENT DIAGRAM Project:
011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PUMP AUXILIARY SEAL PLAN DETAILS No 9
Item Tags :
ORIGINAL SIGNED IN PROJECT FILE
Syst./ S-Syst.:
Discipline: PRO
COMPANY Document N° Contractor/Vendor Document N°
SA-JER-DS011-TRJR-480252 2271-011-PID-0021-171
Electronic Filename SA-JER-DS011-TRJR-480252.pid REV:
03
Sheet: 9 of 11
SCALE: NONE Format:
A1
41
41
40
40
39
API PLAN 23/75
API PLAN 21/53B
COOLING: M PUMP TYPE: BB2
COOLING: M PUMP TYPE: OH2
38
39 38
37
37
NOTE 2
36
36
35
H
PI
34
(B) XXXX
HPT 29
33
NOTE 4 32
(A)
PI XXXX
(A)
H
35
PI
XXXX (D)
HPT
TRJR VENDOR
TRJR VENDOR
RO TRJR VENDOR XXXX (A)
31
PI
PT XXXX
PT XXXX
PI XXXX
(B)
RO XXXX
29
L
TRJR VENDOR
NOTE 4
VENDOR TRJR (B)
PZV XXXX
(C)
LFL (A)
34
(B) XXXX
LFL (B)
30
(A)
33
PT XXXX
PI XXXX
32 31 30
NOTE 5
29
29
LG XXXX
TRJR VENDOR 28
H
LI 27
(A)
LT XXXX
XXXX
(A)
(B)
(A)
VENDOR TRJR NOTE 1
26
TI XXXX
VENDOR TRJR LT XXXX
(B)
NOTE 3 LI
XXXX (B)
VENDOR TRJR NOTE 1
TI XXXX (A)
LG XXXX
28
H
27
(B) TI XXXX
26
(B)
25
25
24
24
D 23
D
V
TRJR VENDOR
NPT PLUGED
22
V
NPT PLUGED
RO XXXX
21 20
5
4
1
4
18
3
VENDOR TRJR
VENDOR TRJR 2" OLW
14
D 18 17
D VENDOR TRJR NOTE 1
011-SP-XXXX (B)
16
011-SP-XXXX 011-SP-XXXX (A)
15
(B)
VENDOR
TRJR
VENDOR OLW
13
19
3
2" OLW
VENDOR TRJR NOTE 1
011-SP-XXXX (A)
20
12 4 14 15 2
17
15
21
7
2
16
22
TI XXXX (A)
6 5 11
11
19
23
D
D
V
OLW
CWS
32
14
TRJR
13
CWS
32
12
12
CWR
32
11
CWR
32
11
10
10
9
9
8
8
7
7
011-RO-XXXX(A) 011-RO-XXXX(B)
PUMP
TYPE
011-G-0015-A
BB2
RO-0910
RO-0911
011-G-0015-B
BB2
RO-0920
RO-0921
011-PI-XXXX(A)
011-LG-XXXX(B)
011-LI-XXXX(A)
011LI-XXXX(B)
011-LT-XXXX(A)
011-LT-XXXX(B)
011-PT-XXXX(A)
011-PT-XXXX(B)
PUMP
TYPE
LG-0910
LG-0912
LI-0911
LI-0913
LT-0911
LT-0913
PT-0911
PT-0913
011-G-0005-A
OH2
PZV-0950
PI-0950
PI-0951
LG-0920
LG-0922
LI-0921
LI-0923
LT-0921
LT-0923
PT-0921
PT-0923
011-G-0005-B
OH2
PZV-0955
PI-0955
PI-0956
011-LG-XXXX(A)
011-PZV-XXXX
011-PI-XXXX(B)
011-PT-XXXX
011-SP-XXXX(A) 011-SP-XXXX(B)
6 5
6
PT-0951
SP-0950
SP-0951
PT-0956
SP-0955
SP-0956
5
4
4
2
011-SP-XXXX(B) 011-TI-XXXX(A)
011-TI-XXXX(B)
PUMP
011-PI-XXXX(A)
011-PI-XXXX(B)
011-PI-XXXX(C)
011-PI-XXXX(D)
011-SP-XXXX(A)
011-G-0015-A
PI-0910
PI-0911
PI-0912
PI-0913
SP-0911
SP-0912
TI-0913
TI-0914
011-G-0005-A
011-G-0015-B
PI-0920
PI-0921
PI-0922
PI-0923
SP-0921
SP-0922
TI-0923
TI-0924
011-G-0005-B
3
PUMP
011-RO-XXXX
CWS LINE No
CWR LINE No
P&ID NUMBER
011-TI-XXXX(A)
011-TI-XXXX(B)
RO-0950
TI-0952
TI-0951
1"-CWS-011171321-101CS1P-N 1"-CWR-011171321-101CS1P-N 2"-OLW-011171343-101CS1P-N
SA-JER-DS011-TRJR-480047
RO-0955
TI-0957
TI-0956
1"-CWS-011171322-101CS1P-N 1"-CWR-011171322-101CS1P-N 2"-OLW-011171344-101CS1P-N
SA-JER-DS011-TRJR-480047
OLW LINE No
3 2
1
1
PUMP
CWS LINE No
CWR LINE No
OLW LINE No
LFL LINE No (A)
011-G-0015-A
1-1/2"-CWS-011171339-101CS1P-N
1-1/2"-CWR-011171339-101CS1P-N
2"-OLW-011171341-101CS1P-N
3/4"-LFL-011171361-101CH2F-N
3/4"-LFL-011171362-101CH2F-N
SA-JER-DS011-TRJR-480096
011-G-0015-B
1-1/2"-CWS-011171340-101CS1P-N
1-1/2"-CWR-011171340-101CS1P-N
2"-OLW-011171342-101CS1P-N
3/4"-LFL-011171363-101CH2F-N
3/4"-LFL-011171364-101CH2F-N
SA-JER-DS011-TRJR-480096
LFL LINE No (B)
P&ID NUMBER
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
01
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
00
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MVF / STG
AVS / MAC
JAL
PREPARED BY
CHECKED BY
REV
LEGEND 1
CASING VENT
2
PUMP DRAIN
3
BASE PLATE DRAIN
4
FLUSH SEAL CHAMBER INLET (FI)
5
FLUSH SEAL CHAMBER OUTLET (FO)
6
BARRIER / BUFFER FLUID SEAL CHAMBER INLET (LBI)
7
BARRIER / BUFFER FLUID SEAL CHAMBER OUTLET (LBO)
8
GAS BUFFER INLET (GBI)
9
CONTAINMENT SEAL VENT (CSV)
10 CONTAINMENT SEAL DRAIN (CSD) 11 SEAL QUENCH / DRAIN (D) 12 FROM PUMP DISCHARGE 13 TO PUMP SUCTION 14 BEARING HOUSING COOLING INLET. 15 BEARING HOUSING COOLING OUTLET. This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- FOR DRAIN AND VENT DESTINATION AND DETAILS REFER TO PROCESS DRAWING. 2- NITROGEN QUICK BLADDER CONNECTION. 3- BARRIER FLUID FILLING CONNECTION. 4- MAKE CONNECTION ON TOP OF PIPE. 5- RELIEF VALVE SHALL BE ROUTED TO DRAIN PAN.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS. DESCRIPTION 011-073 19 N.A. 011-072 20 FUEL OIL 011-073 21 FUEL GAS 22 N.A. 011-071 23 N.A. 24 N.A. 25 CLOSED DRAIN 26 N.A. 011-071 27 L.P. NITROGEN 28 H.P. FLARE 011-071 29 L.P. FLARE 30 SOUR/ACID FLARE 011-071 011-071 31 PILOT GAS 011-071 32 AUX COOLING WATER 011-074 011-074
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY 011-078 011-074
PIPING AND INSTRUMENT DIAGRAM Project:
011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PUMP AUXILIARY SEAL PLAN DETAILS No 10
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480253.pid
Discipline: PRO
SA-JER-DS011-TRJR-480253 2271-011-PID-0021-171
REV:
03
Sheet: 10 of 11
SCALE: NONE Format:
A1
41
41
40
40
011-D-0036 LUBE OIL TANK
011-S-0008-A/ B LUBE OIL FILTERS
39
011-F-0004 LUBE OIL HEADER
011-E-0044-A / B LUBE OIL COOLERS
39
38
38
1-1/2"-LUB-011446401-101SD0P-N
37
37
PDI 0607
36
H
TI
H
36
0615
35
35
34
34
UC
33
2oo3
PI 0611
PI 0610
L
PDT
ZC 0397
33
0607
LL
32
32
011-S-0008-A 31
3/4" PI 0609
30
PT 0611 GB
29
INST PIPING
28
TRJR
27
3/4"
GB
3/4"
PT
PT
PT
0610 A
0610 B
0610 C
GB
3/4"
GB
0615 GB
3/4"
3/4"
VENDOR
N2
1/2"
NOTE 12 INST PIPING
PCV 0608
3/4" 1/2"
D
NOTE 1
+
D
TCV 0633
3/4"
3"x1-1/2"
2"
3"x1-1/2"
NC 3/4"
1-1/2"
3/4"
V
3/4"
D
1-1/2"
3/4" D
+
19
2"-CWR-011446306-101CS1P-N
20 19
VENDOR
18
TRJR
1"-CWR-011446305-101CS1P-N
1-1/2"-LUB-011446407-101SD0P-N
1-1/2"-CWR-011446301-101CS1P-N 1-1/2" N6
1-1/2"-CWR-011446302-101CS1P-N
16
17
32 2973
16
3"x1-1/2"
TUBING
2"
NOTE 12
10 9
H
1-1/2"x1" FC 3/4"
1-1/2"-LUB-011446412-101SD0P-N
11
14
1-1/2"-LUB-011446405-101SD0P-N
1-1/2"x1"
12
15
3"x1-1/2"
+
13
TI 0619
PCV 0606
14
7
011-SP-0605
+
17
LI 0601
21
1"F2" 7.27 TZV 0605
NOTE 11
RO 0606
1"-CWR-011446303-101CS1P-N 1-1/2"
UC
22
1-1/2"
+
+
8
3/4" D
1-1/2"
TZV 0604
NOTE 11
D
3/4"
+
1"F2" 7.27
011-SP-0604
15
23
T2
1-1/2" NOTE 1
18
24
T1
S1
2"-CWR-011446304-101CS1P-N 20
1-1/2"
011-E-0044-B S1
1-1/2"
V
3/4"
S2
S2
T2
NC
D
V
3/4"
1-1/2"
1-1/2"
011-E-0044-A
011-S-0008-B
21
V
T1
1-1/2" 3/4"
28
26
NOTE 1
1-1/2"
22
6912
27
FC
NC
23
LUBE OIL SUPPLY TO 011-G-0001B
32 2972
25
V
1/2"
1-1/2"-CWS-011446301-101CS1P-N
1-1/2"-LUB-011446406-101SD0P-N
1"
24
29
1-1/2"-CWS-011446302-101CS1P-N
+
1-1/2"
25
TRJR
1-1/2" N5 2"
RO 0607
NOTE 1 3/4"
3/4"
0616
1-1/2"
FO
TE 0615
TI
INST PIPING
3/4"
+
1/2"-LUB-011446413-101SD0P-N
30
1-1/2" VENDOR
TUBING
1/2"
1-1/2"
26
31
TT
V
13
1-1/2"-LUB-011446405-101SD0P-N
12
D
3/4"D1" 11.00
11
+
1"
10
PZV 0603 +
1"-LUB-011446411-101SD0P-N
9
CL300 1-1/2"-LUB-011446405-101SD0P-N
8
3/4"-LUB-011446408-101SD0P-N
L
6"-LUB-011446402-101SD0P-N
6
7
LUBE OIL RETURN FROM 011-G-0001B
6"-LUB-011446402-101SD0P-N 3/4"D1" 11.00
6913
6
+
1"-LUB-011446410-101SD0P-N 5
LT
CL300
+
0601
4 3
NOTE 3 1"
1-1/2" NPT DRAIN
2
CL150
1"-LUB-011446411-101SD0P-N
1
TSHL 0618 1-1/2"
N10 NOTE 2 1" 6"
CL300 CL300
N1
CL150
TI 0614
M
ZC
3/4" NC 2" 2"
TE 0613
2"
N8
NOTE 8
011-F-0004
2"-LUB-011446404-101SD0P-N D
0600
2"
2"
2"
011-D-0036 TT
TI
0613
0613
H
D
PI GB
011-G-0038-B
M
1
1-1/2"
2"
D
M
1-1/2" TYP 4
MCC
GM 0038 A
MCC
TYP. 4
GM 0038 B
UC
L
ZC
ZC
011-G-0038-A / B LUBE OIL PUMPS
0004
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND. TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
mm mm barg °C barg °C
m³/h barg barg barg °C kg/m³
011-G-0038-A / B SCREW 9.2 8.70 7.70 12.00 55.00 840.0
FILTERS TYPE DES. CAPACITY OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP.
011-D-0036 HORIZONTAL 1000.0 1500.0 0.00 50.00 0.00 100.00
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
m³/h barg °C barg °C
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-S-0008-A / B CARTRIDGE 9.2 5.00 50.00 12.00 100.00 011-E-0044-A / B AEM 5.00 5.00 55.50 34.50 50.00 44.50 12.10 35.00 100.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
2
ORIGINAL SIGNED IN PROJECT FILE
FM
GENERAL NOTES
3
0605
GB
2"-LUB-011446403-101SDOP-N
2"
NC
011-G-0038-A
1-1/2" 2"
3/4"
2"
4
INST
3/4"
PI
1-1/2"
2"
LG
N7
MCC
3/4"
3/4"-LUB-011446409-101SD0P-N
PIPING 0604
TYP 11 D
INST
2"
CL150
CL150
PIPING 1-1/2" 1" 1"
2"
NOTE 4 NOTE 5
N12 NOTE 9
N11 NOTE 10
1"
NOTE 7 NOTE 6 TSHH 0617
N9 NOTE 2 1"
5
PZV 0602
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX011-TT-0001.) 1 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER 4 POTABLE WATER NOTES 5 DEMI WATER 1- THREE WAY TRANSFER VALVES. 6 N.A. 2- SPARE. 7 N.A. 3- LUBE OIL PURIFIER RETURN. 4- LUBE OIL PURIFIER SUCTION. 8 N.A. 5- HEATER WITH 480V AC, 3PH, 60HZ. 9 HP STEAM 6- HIGH TEMPERATURE CUTOUT AT 15.56°C (60°F). 10 MP STEAM 7- OVER TEMPERATURE CUTOUT AT 85°C (185°F). 11 LP STEAM 8- EARTH. 12 HP CONDENSATE 9- 2" VENT / BREATHER. 13 MP CONDENSATE 10- FILL STRAINER. 14 LP CONDENSATE 11- AT GRADE AT SAFE LOCATION. 12- INSTRUMENT TUBING LINE. 15 BFW 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A.
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
01
14-JUL-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
00
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
PREPARED BY
CHECKED BY
REV
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PUMP AUXILIARY DETAILS FOR 011-G-0001A/B No 1
011-074 011-078 Item Tags :
011-075 011-080 011-077
011-S-0008 A/B, 011-D-0036, 011-F-0004, 011-E-0044 A/B, 011-G-0038 A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480254 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480254 2271-011-PID-0021-446
REV: 03
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
40
40
39
39
38 6912
38
1-1/2"-LUB-011446401-101SD0P-N
LUBE OIL SUPPLY FROM LUBE OIL SYSTEM
37 36 35
37
ZC 0397
VAHH 0600 RA
IC 0600 VMS
33
ZC 0397
VAHH 0600 RB
34
ZC 0397
IC 0620
ZC 0397
VAHH 0620 RB
VMS
ZAHH ZAHH 0600 AA 0600 AB
36
VAHH 0620 RA
35 34
ZAHH ZAHH 0620 AA 0620 AB
33
32
30
IC 0600
SI
VMS VMS
1-1/2" 29
ZY 0601 A
27
HH H VMS
TI 0600
H VMS
VENDOR
25 24 23 22 21
VY 0602 R
1-1/2" CL150
TRJR
26
HH
TE
TE
0600 B
0600 A
HH
VY H 0603 R VMS
VY 0604 R
HH
HH
VY
H 0605 R VMS
H VMS
ZY 0601 A
TI 0600
H VMS
VT 0602 RX
VT 0602 RY
TE 0602 A
TE 0602 B
TE 0603 A
TE 0603 B
+
OUTLET
1/2" NOTE 1
INLET
1/2" NOTE 1 1-1/2"
1-1/2"
VMS
TE 0607 A
TE 0607 C
TE 0608 A
TE 0608 D
TE 0609 B
TE 0609 D
TE 0607 B
TE 0607 D
TE 0608 B
TE 0608 C
TE 0609 A
TE 0609 C
VT 0604 RY RO 0604
RO 0605
+
HH
HH H VMS
VY 0622 R
1-1/2" CL150
VENDOR
RO 0602
ZT 0601 AB
SI
VMS
TRJR
+
19
31
1-1/2"
HH
HH H VMS
TI 0603
0600 K
RO 0603
20
18
HH H VMS
TI 0602
H VMS
MCC
LN08
1-1/2"-LUB-011446414-101SD0P-N
28
HH
IC 0620
TE
TE
0620 B
0620 A
HH H VMS
TI 0623
VT 0622 RX
VT 0622 RY
TE 0622 A
TE 0622 B
TE 0623 A
TE 0627 A
TE 0627 C
TE 0628 A
TE 0628 D
TE 0629 B
TE 0629 D
25
TE 0627 B
TE 0627 D
TE 0628 B
TE 0628 C
TE 0629 A
TE 0629 C
24
VT 0624 RY
OUTLET
1/2" NOTE 1
INLET
1-1/2"
21
RO 0624
RO 0625
+
+
20
VT
VT 0623 RX
0624 RX
VT 0623 RY
19
1/2" NOTE 1 1-1/2"
ST 0620 K
1/2" NOTE 1 1-1/2"
VT 0625 RX
18 17
17
VT 16
ZT 0601 AA
2"
3"
3"
15
TE 0601 B
13
011-G-0001-A
TE 0601 A
0611
0601 9
HH H 3" VMS
TE 0604 B
TE 0604 A
TI
16
0625 RY
TI 0612
TI 0605
TE 0605 A
TE 0621 B
TE 0605 B
TE 0621 A
NOTE 3 3" CL150 TI 0604
HH H VMS
TI 0605
HH H VMS
TI 0621 1"
HH H 3" VMS
011-SP-0622 TE 0624 B
TE 0624 A
15
011-SP-0623
TI 0632
14
TI 0626
TE 0625 A
TE 0625 B
13 12
3"-LUB-011446416-101SD0P-N
LNOB
TRJR
0631 011-SP-0621
011-SP-0620
VENDOR
011-GM-0001-B
TI
011-G-0001-B
0630
3"-LUB-011446417-101SD0P-N
LNOB
TI
10
3"
3"
3"
3"
011-SP-0603
011-SP-0602
011-SP-0600A
011-SP-0600
12
VENDOR TRJR
0605 RY
011-GM-0001-A
TI
0610
3"
VT ZT 0621 AA
TI
14
11
28
22
NOTE 1 1-1/2"
ZT 0621 AB
H 0625 R VMS
TE 0623 B
1/2" VT 0605 RX
VY
H VMS
23
RO 0622 1/2" NOTE 1 1-1/2"
VY 0624 R
29
HH
26
+
1/2" NOTE 1 1-1/2"
VY H 0623 R VMS
+
0604 RX ST 0600 K
HH H VMS
HH
27
+
VT 0603 RY
TI 0622
HH
RO 0623
VT
VT 0603 RX
H VMS
30
MCC
0620 K
LN08
1-1/2"-LUB-011446415-101SD0P-N
31
32
NOTE 3 11
3" CL150 TI 0624
HH H VMS
TI 0625
HH H VMS
10
1"
9
6"x3" 8 7 6913
LUBE OIL RETURN TO LUBE OIL SYSTEM
6"-LUB-011446402-101SD0P-N
2" NPT BASE PLATE DRAIN
8
2" NPT BASE PLATE DRAIN
6"x3"
7
6
1"-IAI-011230305-301CG2P-N
1"-IAI-011230304-301CG2P-N
MCC
6
5
5
4
4
3
MHSS
MHSR
MHSS
MHSR
MHS
MHS
MHS
G0038 AL
G0038 AL
G0038 BL
G0038 BL
G0038 AL
G0038 BL
F0004 L
MAIN OIL PUMP MAIN OIL PUMP A STOP A START
2
AUX OIL PUMP AUX OIL PUMP MAIN OIL PUMP A AUX OIL PUMP B B STOP B START LOCAL/REMOTE LOCAL/REMOTE
3
OIL HEATER ON/OFF
2
ORIGINAL SIGNED IN PROJECT FILE
LOCAL PANEL TAG: 011-LP-G0001A/B MAIN PUMP A RUNNING
MAIN PUMP B RUNNING
MAIN OIL PUMP A RUNNING
AUX OIL PUMP B RUNNING
READY TO START MAIN PUMP A
MXL
MXL
MXL
MXL
XL
G0001 AL
G0001 BL
G0038 AL
G0038 BL
0600 L
1
NOTE 2
COMMON ALARM MAIN PUMP A
COMMON ALARM MAIN PUMP B
TRIP MAIN PUMP A
TRIP MAIN PUMP B
LAMP TEST
XL
UA
UA
UA
UA
HS
0620 L
0600 L
0620 L
0601 L
0621 L
0600 L
READY TO START MAIN PUMP B
1"-IAI-011230304-301CG2P-N
1
DCS
3"-IAI-011074301 DS011-TRJR-480211 10799
GENERAL NOTES
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER 4 POTABLE WATER NOTES 5 DEMI WATER 6 N.A. 1- FOR PI CONNECTION. 2- MONITORING SYSTEM WILL COMMUNICATE INDIVIDUALLY ALL INDICATIONS, ALARMS AND TRIP WITH THE DCS. ADDITIONALLY, A REDUNDANT COMMON TRIP 7 N.A. SIGNAL WILL BE WIRED TO THE ESD. 8 N.A. 3- INSTRUMENT AIR FOR ELECTRICAL PANEL 9 HP STEAM 10 MP STEAM 11 LP STEAM 12 HP CONDENSATE 13 MP CONDENSATE 14 LP CONDENSATE 15 BFW 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A. This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
01
14-JUL-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
00
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
PREPARED BY
CHECKED BY
REV
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PUMP AUXILIARY DETAILS FOR 011-G-0001A/B No 2
011-074 011-078 Item Tags :
011-075 011-080 011-077
011-G-0001A/B, 011-GM-0001A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480255.pid
Discipline: PRO
SA-JER-DS011-TRJR-480255 2271-011-PID-0021-446
REV: 03
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
41
40
40
011-F-0005 LUBE OIL HEATER
011-S-0009-A / B LUBE OIL FILTERS
39
011-E-0045-A / B LUBE OIL COOLERS
011-D-0037 LUBE OIL RESERVOIR
39
38
LUBE OIL SUPPLY TO 011-G-0002B
38 6918
37
37
36
36
1-1/2"-LUB-011450401-101SD0P-N
35
UC
2oo3
PI 0661
33
L
H
PDI 0657
34
PI 0660
34
ZC 0397
33
LL
32
PDT
PI 0659
PT 0661 GB
GB
PT
PT
PT
0660 A
0660 B
0660 C
GB
GB
011-S-0009-A
28
TRJR
3/4"
3/4"
3/4"
VENDOR INST PIPING
PCV 0658
3/4"
+
3/4" 3/4"
3/4"
D
TE 0665
TI
INST PIPING
0666
1-1/2" 1-1/2" N2
1-1/2"
1-1/2"-LUB-011450407-101SD0P-N
RO 0655
NOTE 1
FO
N5
3/4"
D
25
3/4"
1-1/2"
25
3/4"
1-1/2"
011-S-0009-B
3/4"
V
V
3/4"
T1
3/4"
1-1/2"
S1
3/4"
D
V
3/4"
1-1/2"
24
T1
011-E-0045-B
T2
1-1/2"
V
S2
011-E-0045-A
NC
D
1-1/2" S2
1-1/2"
22
26
NOTE 1
1-1/2"
NC
23
1-1/2"
1-1/2"
D
3/4"
23
T2
S1
3/4"
D
22
1-1/2"
D
3/4"
NOTE 1
21 20
+
1"F2" 7.27
011-SP-0651
+
19
21
2"-CWR-011450304-101CS1P-N 1"F2" 7.27
2"-CWR-011450305-101CS1P-N 1-1/2"
011-SP-0652
20
TZV 0655 +
TZV 0654 +
RO 0654
19
+
18
NOTE 11
1"-CWR-011450307-101CS1P-N
VENDOR
N6
1-1/2"-LUB-011450409-101SD0P-N NOTE 12
10 9
0651
1-1/2" FC 3/4"
1-1/2"-LUB-011450413-101SD0P-N
11
H
14
1-1/2"-LUB-011450417-101SD0P-N
1-1/2"
12
15
3"x1-1/2"
+
13
TI 0669
PCV 0656
14
LI
16
3"x1-1/2" 2"
UC
17
32 6886
1-1/2"
15
8
1-1/2"-CWR-011450301-101CS1P-N
1-1/2"-CWR-011450303-101CS1P-N
16
TUBING
18
TRJR
NOTE 11 1"-CWR-011450306-101CS1P-N
17
13
1-1/2"-LUB-011450414-101SD0P-N
12
D
3/4"D1" 11.00
1" NC 1"-LUB-011450416-101SD0P-N
+
11
PZV 0653
10
+
9
1-1/2"-LUB-011450417-101SD0P-N
8
3/4"-LUB-011450415-101SD0P-N
L
7
6"-LUB-011450402-101SD0P-N
6"-LUB-011450402-101SD0P-N
6
LUBE OIL RETURN FROM 011-G-0002B
3/4"D1" 11.00
7 6919
+
1"-LUB-011450419-101SD0P-N 5
LT
+
PIPING
3
NOTE 3 1"
1-1/2" NPT DRAIN
2
CL150 1" 1
CL150
N9 NOTE 5 1"
N10 NOTE 5 1" 6"
CL150 CL150
N12 NOTE 4
N1
CL150
NOTE 6 NOTE 10 NOTE 9 TSHH 0684
TSHL 0685 1-1/2"
NOTE 2 N11 2" 2"
CL150 TI
011-F-0005 NOTE 7
M
1-1/2"
CL150
NC 2"
0664 TE 0663
2"
LG 0650
D
NOTE 8
1/2"
2"
2"
2" 2"
3/4" N7
MCC
2"
D
TI
0663
0663
H
PI 0655
GB
3
GB
1
1-1/2"
1"
2"-LUB-011450411-101SDOP-N D
M
1/2" TYP.4
TYP.4
GM 0039 A
MCC
MCC
GM 0039 B
UC
L
ZC
ZC
FM
011-G-0039-A / B LUBE OIL PUMPS
0005
GENERAL NOTES
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
mm mm barg °C barg °C
m³/h barg barg barg °C kg/m³
011-G-0039-A / B SCREW TYPE 9.2 8.70 7.70 12.00 55.00 840.0
FILTERS TYPE DES. CAPACITY OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP.
011-D-0037 HORIZONTAL 1000.0 1500.0 0.00 50.00 0.00 100.00
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
m³/h barg °C barg °C
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-S-0009-A / B CARTRIDGE 9.2 5.00 50.00 12.00 100.00 011-E-0045-A / B AEM 5.60 5.00 54.30 34.50 50.00 36.20 12.00 9.00 100.00 3.2
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
2
011-G-0039-B
M
011-D-0037 TT
4
INST
3/4"
PI
1-1/2"
2"
TYP 11 ZC
2"-LUB-011450412-101SD0P-N
PIPING 0654
011-G-0039-A 2"
INST
3/4"
3/4"-LUB-011450418-101SD0P-N
1" 1"
3/4"
2"
NC
N8
6 5
PZV 0652
0651
4
TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
28
1-1/2"
V
1-1/2"
32 6885
27
FC
NC
1"
24
1-1/2"-CWS-011450301-101CS1P-N
1-1/2"-LUB-011450408-101SD0P-N
3"x1-1/2"
3"x1-1/2"
NOTE 1
+
29
+
2"
2"
1-1/2"
TRJR
1-1/2"-CWS-011450303-101CS1P-N
TCV 0683
VENDOR
27 26
30
1-1/2"
GB NOTE 12 TUBING
3/4"
31
3/4" V
1-1/2"
29
INST PIPING
32
H
TI 0665
0657 31 30
35
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER 4 POTABLE WATER NOTES 5 DEMI WATER 1- THREE WAY TRANSFER VALVES. 6 N.A. 2- AIR BREATHER. 7 N.A. 3- LUBE OIL PURIFIER RETURN. 4- FILL STRAINER. 8 N.A. 5- SPARE. 9 HP STEAM 6- LUBE OIL PURIFIER SUCTION. 10 MP STEAM 7- HEATER WITH 480V AC, 3PH, 60HZ. 11 LP STEAM 8- EARTH. 12 HP CONDENSATE 9- HIGH TEMPERATURE CUTOUT AT 15.56°C (60°F). 13 MP CONDENSATE 10- OVER TEMPERATURE CUTOUT AT 85°C (185°F). 14 LP CONDENSATE 11- AT GRADE AT SAFE LOCATION. 12- INSTRUMENT TUBING LINE. 15 BFW 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A.
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
01
14-JUL-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
00
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
PREPARED BY
CHECKED BY
REV
COMPANY STATUS
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PUMP AUXILIARY DETAILS FOR 011-G-0002A/B No 1
Project:
011-074 011-078 Item Tags :
011-075 011-080 011-077
011-S-0009 A/B, 011-E-0045 A/B, 011-F-0005, 011-D-0037, 011-G-0039 A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480256 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480256 2271-011-PID-0021-450
REV: 03
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
40
40
39
39
38 6918
38
1-1/2"-LUB-011450401-101SD0P-N LUBE OIL SUPPLY FROM LUBE OIL SYSTEM
37 36 35
37
ZC 0397
VAHH 0650 RA
IC 0650 R VMS
33
ZC 0397
VAHH 0650 RB
34
ZC 0397
IC 0670 R
ZC 0397
VAHH 0670 RB
VMS
ZAHH ZAHH 0650 AA 0650 AB
36
VAHH 0670 RA
35 34
ZAHH ZAHH 0670 AA 0670 AB
33
32
32
31 30
31
IC 0650
SI
VMS
MCC
0650 K
1-1/2"
IC 0670
SI
VMS VMS
1-1/2"
VMS
30
MCC
0678 K
29
29
28
ZY 0651 A
TI 0650
H VMS
HH
HH H VMS
27
VY 0652 R
1-1/2" CL150
25 24 23 22 21
TE
TE
0650 B
0650 A
HH H VMS
TI 0652
VY H 0653 R VMS
VMS
VY 0654 R
VT 0652 RX
VT 0652 RY
TE 0652 A
TE 0652 B
TE 0653 A
RO 0650
1/2" NOTE 1
+
1/2" NOTE 1 1-1/2"
ZT 0651 AB
VY
H 0655 R VMS
H VMS
TE 0653 B
ZY 0671 A
HH H H VMS VMS
1-1/2"
17
TE 0660 A
TE 0660 C
TE 0661 A
TE 0661 D
TE 0662 B
TE 0662 D
TE 0660 B
TE 0660 D
TE 0661 B
TE 0661 C
TE 0662 A
TE 0662 C
VT 0654 RY
+
19
HH
HH
HH
TI 0670
VY 0672 R
1-1/2" CL150
RO 0651
20
18
HH H
TI 0653
HH
LN0B
1-1/2"-LUB-011450403-101SD0P-N
26
H VMS
HH
RO 0652
RO 0653
+
TE
TE
0670 B
0670 A
H VMS
TI 0672
HH H VMS
VT 0672 RX
VT 0672 RY
TE 0672 A
TE 0672 B
TE 0673 A
ST 0650 K
VT 0655 RX
TE 0680 A
TE 0680 C
TE 0681 A
TE 0681 D
TE 0682 B
TE 0682 D
TE 0680 B
TE 0680 D
TE 0681 B
TE 0681 C
TE 0682 A
TE 0682 C
25 24
22
VT 0674 RY
1/2" NOTE 1
1-1/2"
21
RO 0672
RO 0673
+
+
20
VT
VT 0673 RX
19
0674 RX
VT 0673 RY
1/2" NOTE 1 1-1/2"
ST 0670 K
1/2" NOTE 1 1-1/2"
VT 0675 RX
ZT
3"
3"
3"
3"
0651 AA 15
TI 0658
14
TE 0651 B
13
011-G-0002-A
TE 0651 A
011-SP-0654
10
TI 0651
9
LUBE OIL RETURN TO LUBE OIL SYSTEM
6"-LUB-011450402-101SD0P-N
TE 0654 B
TE 0654 A
3" TI
TI
TI
0667
0668
3"
TE 0655 A
3"
TE 0671 B
TE 0655 B
TE 0671 A
3" CL150 TI 0654
6"x3"
HH H VMS
HH H VMS
TI 0655
0679
TI 0671 1"
HH H 3" VMS
TE 0674 B
TE 0674 A
15 14
TI
TI
0687
0688
TE 0675 A
TE 0675 B
13 12
3"-LUB-011450406-101SD0P-N
LN0B
VENDOR TRJR
16
0675 RY
011-SP-0661
011-SP-0660
011-SP-0659
011-SP-0658
3"
011-GM-0002-B
TI
011-G-0002-B
0678
011-SP-0657
3"
3"
0671 AA
NOTE 3
6"x3"
8 7 6919
HH H 3" VMS
0655 RY
3"-LUB-011450404-101SD0P-N
LN0B
VENDOR TRJR
011-SP-0656
011-SP-0655
12 11
0659
3"
3"
VT ZT
011-GM-0002-A
TI
18 17
VT 16
28
23
1/2" NOTE 1 1-1/2"
ZT 0671 AB
H 0675 R VMS
TE 0673 B
+
0654 RX
VY
H VMS
26
RO 0670 1/2" NOTE 1 1-1/2"
VY 0674 R
HH
27
+
1/2" NOTE 1 1-1/2"
VY H 0673 R VMS
HH
RO 0671
VT
VT 0653 RY
HH H VMS
TI 0673
+
VT 0653 RX
HH
LN0B
1-1/2"-LUB-011450405-101SD0P-N
HH
NOTE 3 11
3" CL150 TI 0654
HH H VMS
TI 0675
HH H VMS
10
1"
9
2" NPT BASEPLATE DRAIN
2" NPT BASEPLATE DRAIN
8 7
1"-IAI-011230306-301CG2P-N
6
1"-IAI-011230307-301CG2P-N
6
MCC
5
5
4
4
MHSR
MHSS
MHSR
MHS
MHS
MHS
G0039 AL
G0039 AL
G0039 BL
G0039 BL
G0039 AL
G0039 BL
F0005 L
MAIN OIL PUMP MAIN OIL PUMP A STOP A START
2 1
MAIN OIL PUMP MAIN OIL PUMP MAIN OIL PUMP A AUX OIL PUMP B B STOP B START LOCAL/REMOTE LOCAL/REMOTE
LOCAL PANEL TAG: 011-LP-G0002A/B MAIN PUMP A RUNNING
MAIN PUMP B RUNNING
MAIN OIL PUMP A RUNNING
AUX OIL PUMP B RUNNING
READY TO START MAIN PUMP A
MXL
MXL
MXL
MXL
XL
G0002 AL
G0002 BL
G0039 AL
G0039 BL
0650 L
3
OIL HEATER ON/OFF
2 1
NOTE 2
COMMON ALARM MAIN PUMP A
COMMON ALARM MAIN PUMP B
TRIP MAIN PUMP A
TRIP MAIN PUMP B
LAMP TEST
XL
UA
UA
UA
UA
HS
0670 L
0650 L
0670 L
0651 L
0671 L
0650 L
READY TO START MAIN PUMP B
1"-IAI-011230306-301CG2P-N
3
MHSS
DCS
3"-IAI-011074301 DS011-TRJR-480211 10798
GENERAL NOTES
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 1 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER 4 POTABLE WATER NOTES 5 DEMI WATER 1- FOR PI CONNECTION. 6 N.A. 2- MONITORING SYSTEM WILL COMMUNICATE INDIVIDUALLY ALL INDICATIONS, ALARMS AND TRIP WITH THE DCS. ADDITIONALLY, A REDUNDANT COMMON TRIP 7 N.A. SIGNAL WILL BE WIRED TO THE ESD. 8 N.A. 3- INSTRUMENT AIR FOR ELECTRICAL PANEL 9 HP STEAM 10 MP STEAM 11 LP STEAM 12 HP CONDENSATE 13 MP CONDENSATE 14 LP CONDENSATE 15 BFW 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A. This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
01
14-JUL-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS/MAC
JAL
00
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
REV
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PUMP AUXILIARY DETAILS FOR 011-G-0002A/B No 2
011-074 011-078 Item Tags :
011-075 011-080 011-077
011-G-0002A/B, 011-GM-0002A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480257 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480257 2271-011-PID-0021-450
REV: 03
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
41
40 39
011-E-0046-A - B LUBE OIL COOLERS
011-F-0006 LUBE OIL HEATER
011-S-0010-A - B LUBE OIL FILTERS
40
011-D-0038 LUBE OIL RESERVOIR
39
38
38
H
PDI 0707
37
37
36
36
35
35
1-1/2"-LUB-011460401-101SD0P-N
34
34
2oo3
PI 0710
L
PDT
ZC 0340
0707
GB
LL
0715
32 31
PI 0709
PT 0711 GB
29
INST PIPING
28
TRJR
27
PT
PT
PT
0710 A
0710 B
0710 C
GB
3/4" 3/4"
3/4"
GB
GB
3/4"
31
011-S-0010-A 1-1/2"
1-1/2"-LUB-011460403-101SD0P-N GB
TUBING
NOTE 12
INST PIPING
PCV 0708
3/4"
VENDOR
N2 1-1/2"
3/4" 1-1/2"
3/4"
D
V
3/4"
1-1/2"
3/4"
V
3/4"
D
011-SP-0701
20 19
D
3/4"
18
3/4"
1-1/2"
24
T1 23
1-1/2"
D
T2
S1
1-1/2"
VENDOR
TRJR
V
3/4"
011-E-0046-B S1
1-1/2"
V
S2
011-E-0046-A
21
1"F2" 7.27 +
NOTE 1
1-1/2"
TZV 0704 +
NOTE 7
RO 0704 +
1"-CWR-011460304-101CS1P-N
3/4"
D
D
3/4"
VENDOR 1"F2" 7.27
TRJR
22
1-1/2"
21
+
011-SP-0702
20
TZV 0705 +
19
NOTE 7 18
1"-CWR-011460305-101CS1P-N
N6
17
1-1/2"
VENDOR
1-1/2"-LUB-011460405-101SD0P-N 16
1-1/2"-CWR-011460301-101CS1P-N
6872
16
3"x1-1/2"
TUBING
2"
NOTE 12 +
13
1-1/2" 1-1/2"x1" 1-1/2"-LUB-011460407-101SD0P-N
12 11 10 9
UC
LI 0701
8
H L
1"
TI
15
0719
PCV 0706
14
14
3"x1-1/2"
13
1-1/2"x1" 1-1/2" FC 3/4"
12
D
3/4"D1" 11.00
11
+
1"
10
PZV 0703
NC 1"-LUB-011460413-101SD0P-N
+
1-1/2"-LUB-011460408-101SD0P-N 9
1-1/2"x3/4"
1-1/2"-LUB-011460406-101SD0P-N
8
3/4"-LUB-011460411-101SD0P-N
6"-LUB-011460402-101SD0P-N
7
LUBE OIL RETURN FROM 011-G-0004A/B
3% MIN
6
TRJR VENDOR
5
3
1-1/2" NPT DRAIN
2
CL150 1" NOTE 6
1
NOTE 11 NOTE 10 TRJR VENDOR
TSHH 0734
TSHL 0735 1-1/2"
TRJR VENDOR N10 NOTE 4 1"
NOTE 5 1"
N9 NOTE 4 1"
1"-LUB-011460414-101SD0P-N
CL150
CL150 CL150
N12 NOTE 2
N11 NOTE 3
6"
2"
CL150
CL150 TI
2"
CL150
NOTE 9
M
NC
3/4"
ZC
MCC
2"
2"
2"
FM
2"-LUB-011460409-101SD0P-N
PIPING
0700
2"
3/4"
2"
2"
2"
1/2" 2"
NC
0006
TI 0713
H L
PIPING
4
3/4"
PI
PI 0705
GB
ORIGINAL SIGNED IN PROJECT FILE
011-G-0040-B
M
1
1-1/2"
2"
2"-LUB-011460410-101SDOP-N D
M
1/2"
MCC
TYP 4
GM 0040 A
MCC
TYP. 4
GM 0040 B
ZC
011-G-0040-A/ B LUBE OIL PUMPS
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
01
14-JUL-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
00
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
PREPARED BY
CHECKED BY
REV
GENERAL NOTES
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-E-0046-A / B AEM 5.60 5.00 56.10 34.50 50.00 44.50 12.00 80.00 100.00 1.9 0.01
RESERVOIR TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
011-G-0040-A / B SCREW 4.2 8.70 7.70 12.00 55.00 840.0
FILTERS TYPE DES. CAPACITY OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP.
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
m³/h barg barg barg °C kg/m³
011-D-0038 HORIZONTAL 1000.0 1500.0 0.02 50.00 0.02 100.00
mm mm barg °C barg °C
m³/h barg °C barg °C
011-S-0010-A / B CARTRIDGE. 9.2 5.20 50.00 12.00 100.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
3
GB
2
ZC UC
INST
1-1/2"
2"
011-D-0038 TT 0713
INST
3/4"
D
D N7 NOTE 8
1-1/2"x3/4"
011-G-0040-A
TYP 11 D N8
5
0704
LG TE 0713
PZV 0702
1" 1"
2"
0714
011-F-0006
6
3/4"-LUB-011460412-101SD0P-N 1-1/2"
7
+
+
0701 N1
6923
3/4"D1" 11.00
LT
4
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
17
32
TRJR
1-1/2"-CWR-011460303-101CS1P-N
15
28
26
1-1/2"
S2
T2
3/4"
6922
27
1-1/2"
T1
NC
011-S-0010-B
22
6871
25
1/2"
NC
23
TRJR
NOTE 1
NC
1-1/2"
1-1/2"
LUBE OIL SUPPLY TO 011-G-0004A/B
32
1/2"
1"
24
1-1/2"-CWS-011460301-101CS1P-N
1-1/2"-LUB-011460404-101SD0P-N FC
V
3/4"
VENDOR
3"x1-1/2"
2"
2"
NOTE 1
25
N5 1-1/2"
1-1/2"-CWS-011460303-101CS1P-N TCV 0733
3"x1-1/2" +
D
0716
+
RO 0705
NOTE 1
29
TE 0715
TI
INST PIPING
1-1/2"
FO 3/4"
30
1-1/2"
3/4"
+
1-1/2"
26
32
V
3/4"
30
33
H
TI
2"-CWR-011460306-101CS1P-N
PI 0711
2"-CWR-011460307-101CS1P-N
UC
33
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 1 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER 4 POTABLE WATER NOTES 5 DEMI WATER 1- THREE WAY TRANSFER VALVE. 6 N.A. 2- AIR BREATHER. 7 N.A. 3- FILL STRAINER. 4- SPARE. 8 N.A. 5- LUBE OIL PURIFIER RETURN. 9 HP STEAM 6- LUBE OIL PURIFIER SUCTION. 7- AT GRADE AT SAFE LOCATION. 10 MP STEAM 8- EARTH. 11 LP STEAM 9- HEATER WITH 480V AC, 3PH, 60HZ. 12 HP CONDENSATE 10- HIGH TEMPERATURE CUTOUT AT 15.56°C (60°F). 13 MP CONDENSATE 11- OVER TEMPERATURE CUTOUT AT 85°C (185°F). 12- INSTRUMENT TUBING LINE. 14 LP CONDENSATE 15 BFW 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A.
COMPANY STATUS
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PUMP AUXILIARY DETAILS FOR 011-G-0004A/B No 1
011-074 011-078 Item Tags :
011-075 011-080 011-077
011-S-0010 A/B, 011-F-0006, 011-E-0046 A/B, 011-D-0038, 011-G-0040 A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480258 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480258 2271-011-PID-0021-460
REV: 03
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
40
40
39
39
38 6922
38
1-1/2"-LUB-011460401-101SD0P-N
LUBE OIL SUPPLY FROM LUBE OIL SYSTEM
37 36 35
37
ZC 0340
VAHH 0700 RA
IC 0700 VMS
33
ZC 0340
VAHH 0700 RB
34
ZC 0340
IC 0720
ZC 0340
VAHH 0720 RB
VMS
ZAHH ZAHH 0700 AA 0700 AB
36
VAHH 0720 RA
35 34
ZAHH ZAHH 0720 AA 0720 AB
33
32
30
IC 0700
SI
VMS VMS
1-1/2" 29 28
HH
ZY 0701 A
27
24 23 22
TE
TE
0700 B
0700 A
HH H VMS
TI 0702
HH
VY H 0703 R VMS
VY 0704 R
VT 0702 RX
RO 0700 +
VT 0702 RY
TE 0702 A
TE 0702 B
TE 0703 A
VY
H 0705 R VMS
H VMS
TE 0703 B
OUTLET
1/2" NOTE 1
INLET
1/2" NOTE 1
ZT 0701 AB
HH
HH
ZY 0721 A
TI 0720
H VMS
1-1/2"
1-1/2"
VMS
TE 0710 A
TE 0710 C
TE 0711 A
TE 0711 D
TE 0712 B
TE 0712 D
TE 0710 B
TE 0710 D
TE 0711 B
TE 0711 C
TE 0712 A
TE 0712 C
VT 0704 RY RO 0702
RO 0703
+
HH
HH H VMS
VY 0722 R
1-1/2" CL150
TRJR VENDOR
+
19
SI
VMS 1-1/2"
HH
HH H VMS
TI 0703
0700 K
RO 0701
20
18
H VMS
MCC
31
LN08
1-1/2"-LUB-011460416-101SD0P-N
25
21
VY 0702 R
1-1/2" CL150
TRJR VENDOR
26
HH H VMS
TI 0700
H VMS
HH
IC 0720
TE
TE
0720 B
0720 A
HH H VMS
TI 0723
VT 0722 RX
VT 0722 RY
VT 0705 RX
TE 0722 A
TE 0722 B
TE 0723 A
H 0725 R VMS
TE 0723 B
TE 0730 A
TE 0730 C
TE 0731 A
TE 0731 D
TE 0732 B
TE 0732 D
25
TE 0730 B
TE 0730 D
TE 0731 B
TE 0731 C
TE 0732 A
TE 0732 C
24
VT 0724 RY
OUTLET
1/2" NOTE 1
INLET
1-1/2"
21
RO 0722
RO 0723
+
+
20
VT
VT 0723 RX
0724 RX
VT 0723 RY
19
1/2" NOTE 1 1-1/2"
ST 0720 K
1/2" NOTE 1 1-1/2"
VT 0725 RX
18 17
17
VT 16
ZT
3"
3"
2"
3"
VT ZT
0705 RY
0701 AA TI
011-G-0004-A
0708
011-GM-0004-A
TI
TE 0701 B
011-SP-0705
011-SP-0704
TE 0701 A
12
TI
10
0701 9
7 6923
HH H 3" VMS
TE 0704 A
TI 0717
011-SP-0710
TI 0718
TE 0705 A
TE 0721 B
TE 0705 B NOTE 3
3" CL150
011-SP-0708
TE 0721 A
0704
HH H VMS
TI 0705
HH H VMS
TE 0724 B
TE 0724 A
TI 0721 1"
15 14
011-SP-0711
TI 0737
TI 0738
TE 0725 A
TE 0725 B
13 12
3"-LUB-011460419-101SD0P-N
NOTE 3 11
3" CL150
TRJR TI
011-SP-0709
LNOB
VENDOR
16
0725 RY
0729
011-SP-0707
3"-LUB-011460417-101SD0P-N
LNOB
VENDOR TRJR
11
TE 0704 B
3"
011-GM-0004-B
TI
011-G-0004-B
0728 011-SP-0706
3"
3"
TI
0709
14 13
3"
0721 AA
15
8
28
22
1/2" NOTE 1 1-1/2"
ZT 0721 AB
VY
H VMS
23
RO 0720 1/2" NOTE 1 1-1/2"
VY 0724 R
29
HH
26
+
1/2" NOTE 1 1-1/2"
VY H 0723 R VMS
+
0704 RX ST 0700 K
HH H VMS
HH
27
+
VT 0703 RY
TI 0722
HH
RO 0721
VT
VT 0703 RX
H VMS
30
MCC
0720 K
LN08
1-1/2"-LUB-011460418-101SD0P-N
31
32
HH H 3" VMS
TI 0724
HH H VMS
TI 0725
HH H VMS
10
1"
9
6"-LUB-011460402-101SD0P-N
LUBE OIL RETURN TO LUBE OIL SYSTEM
3% MIN
2" NPT BASE PLATE DRAIN
8
6"x3"
2" NPT BASE PLATE DRAIN 7
6
1"-IAI-011230308-301CG2P-N
MCC
1"-IAI-011230309-301CG2P-N
6
5
5
4
4
MHSR
MHSS
MHSR
MHS
MHS
MHS
G0040 AL
G0040 AL
G0040 BL
G0040 BL
G0040 AL
G0040 BL
F0006 L
MAIN OIL PUMP MAIN OIL PUMP A STOP A START
2 1
AUX OIL PUMP AUX OIL PUMP MAIN OIL PUMP A AUX OIL PUMP B B STOP B START LOCAL/REMOTE LOCAL/REMOTE
LOCAL PANEL TAG: 011-LP-G0004A/B MAIN PUMP A RUNNING
MAIN PUMP B RUNNING
MAIN OIL PUMP A RUNNING
AUX OIL PUMP B RUNNING
READY TO START MAIN PUMP A
MXL
MXL
MXL
MXL
XL
G0004 AL
G0004 BL
G0040 AL
G0040 BL
0700 L
3
OIL HEATER ON/OFF
2 1
NOTE 2
COMMON ALARM MAIN PUMP A
COMMON ALARM MAIN PUMP B
TRIP MAIN PUMP A
TRIP MAIN PUMP B
LAMP TEST
XL
UA
UA
UA
UA
HS
0720 L
0700 L
0720 L
0701 L
0721 L
0700 L
READY TO START MAIN PUMP B
1"-IAI-011230309-301CG2P-N
3
MHSS
DCS
3"-IAI-011074301 DS011-TRJR-480212 10800
GENERAL NOTES
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER 4 POTABLE WATER NOTES 5 DEMI WATER 1- FOR PI CONNECTION. 6 N.A. 2- MONITORING SYSTEM WILL COMMUNICATE INDIVIDUALLY ALL INDICATIONS, ALARMS AND TRIP WITH THE DCS. ADDITIONALLY, A REDUNDANT COMMON TRIP 7 N.A. SIGNAL WILL BE WIRED TO THE ESD. 8 N.A. 3- INSTRUMENT AIR FOR ELECTRICAL PANEL 9 HP STEAM 10 MP STEAM 11 LP STEAM 12 HP CONDENSATE 13 MP CONDENSATE 14 LP CONDENSATE 15 BFW 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A. This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
01
14-JUL-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
00
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
PREPARED BY
CHECKED BY
REV
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PUMP AUXILIARY DETAILS FOR 011-G-0004A/B No 2
011-074 011-078 Item Tags :
011-075 011-080 011-077
011-G-0004A/B, 011-GM-0004A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480259.pid
Discipline: PRO
SA-JER-DS011-TRJR-480259 2271-011-PID-0021-460
REV: 03
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
41
40
011-F-0007 LUBE OIL HEATER
011-S-0011-A/ B LUBE OIL FILTERS
39
011-E-0047-A / B LUBE OIL COOLERS
40
011-D-0039 LUBE OIL RESERVOIR
39
38
38
1-1/2"-LUB-011525401-101SD0P-N 37
37
PDI 0757
36
H
36
35
35
34
34
UC
2oo3
PI 0761
33
L
PI 0760
PDT
ZC 0857
0757
LL
33
H
TI 0765
32 31
32 31
V 3/4" PI 0759
30
PT 0761 GB
GB
PT
PT
PT
0760 A
0760 B
0760 C
GB
GB
011-S-0011-A GB
29
INST PIPING
28
TRJR
3/4"
3/4"
3/4"
3/4"
NOTE 12 TUBING
INST PIPING
PCV 0758
3/4"
VENDOR
VENDOR
1-1/2"
3/4"
3/4" 0766
1-1/2"-LUB-011525406-101SD0P-N
RO 0755 +
NOTE 1
FO
29
1-1/2"-CWS-011525301-101CS1P-N
N5 1-1/2"
2" 3"x1-1/2"
2"
TRJR
1-1/2"-CWS-011525303-101CS1P-N TCV 0783 +
1-1/2"
1-1/2"
TE 0765
TI
INST PIPING
D 3/4"
1-1/2" 1-1/2" CL150 N2
1-1/2"
+
27 26
30
LUBE OIL SUPPLY TO 011-G-0017B
32 6870
6926
27
1-1/2"-LUB-011525407-101SD0P-N
NOTE 1 3"x1-1/2"
28
FC
26
NOTE 1
D 3/4"
25
V 3/4" 1"
24
25
1-1/2"
1-1/2"
1-1/2"
011-S-0011-B
22
3/4" V
1-1/2"
T1
1-1/2"
NC 23
3/4" V
1-1/2"
NC
3/4" V
1-1/2"
S2
S1
1-1/2"
3/4" D
1-1/2"
3/4" D
1-1/2"
3/4" D
3/4" D
22
1-1/2"
21
1"-CWR-011525307-101CS1P-N
1"-CWR-011525306-101CS1P-N 3/4"F1" 7.27
19
3/4"F1" 7.27 +
NOTE 1
+
011-SP-0751
23
T2
S1
21 20
24
011-E-0047-B
T2
D 3/4"
1-1/2" T1
S2
011-E-0047-A
NC
3/4" V
1-1/2"
TZV 0754
NOTE 6
RO 0754
20
TZV 0755
19
+
NOTE 6
+
011-SP-0752
+
18
3/4"-CWR-011525304-101CS1P-N
VENDOR 3/4"-CWR-011525305-101CS1P-N
17
1-1/2"-CWR-011525302-101CS1P-N N6
1-1/2"-LUB-011525408-101SD0P-N
18
TRJR 1-1/2"-CWR-011525301-101CS1P-N 1-1/2"
17
32 6869
16
16
3"x1-1/2"
NOTE 12
2"
15
TI
15
0769 PCV 0756
14 13
14
3"x1-1/2"
+
1-1/2"-LUB-011525409-101SD0P-N
1-1/2"
1-1/2"
13
1-1/2"-LUB-011525411-101SD0P-N
FC 1-1/2"-LUB-011525410-101SD0P-N
12 11 10 9
UC
8
LI 0751
H L
3/4"
12
D
3/4"D1" 11.00
1" NC
+
11
PZV 0753
10
+
1"-LUB-011525416-101SD0P-N
9
CL300 1-1/2"x3/4"
1-1/2"-LUB-011525409-101SD0P-N
8
3/4"-LUB-011525414-101SD0P-N
7
6"-LUB-011525402-101SD0P-N
6"-LUB-011525402-101SD0P-N 3/4"D1" 11.00
6
7 6927
+
1"-LUB-011525417-101SD0P-N 5
CL300
LT
3
NOTE 3 1"
1-1/2" NPT DRAIN
2
CL150 1" NOTE 7
1
CL150
NOTE 4 N9 1" CL150
CL150
2" CL150
CL150
TI 0764
1"-LUB-011525418-101SD0P-N
NOTE 11 NOTE 10 TSHH 0784 TYP 11 ZC
TSHL 0785 1-1/2" D
MCC
NOTE 9
011-F-0007
M
1-1/2"
2" 3/4"
CL150
NC 2" 2"
TE 0763
2"
2"
2"
2" 3/4"
0754
2"
H
1
1-1/2"
2"
1/2"
M
UC
TYP 4
GM 0041 A
MCC
ZC
TYP. 4
GM 0041 B
ZC
L
FM
011-G-0041-A / B LUBE OIL PUMPS
0007
GENERAL NOTES
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
mm mm barg °C barg °C
m³/h barg barg barg °C kg/m³
011-G-0041-A SCREW 9.2 8.70 7.70 12.00 55.00 840.0
FILTERS TYPE DES. CAPACITY OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP.
011-D-0039 HORIZONTAL 1000.0 1500.0 0.00 50.00 0.00 100.00
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
m³/h barg °C barg °C
SHELL/TUBE SHELL/TUBE IN/OUT IN/OUT
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h
011-S-0011-A/ B CARTRIDGE 9.2 5.40 50.00 12.00 100.00 011-E-0047-A / B AEM 5.60 5.00 55.00 34.50 50.00 44.50 12.00 35.00 100.00 1.3
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
2
D
011-D-0039 TI 0763
3
GB
2"-LUB-011525413-101SDOP-N 2" D
PI 0755
GB
011-G-0041-B
M
4
INST
3/4"
PI
1-1/2"
MCC TT 0763
PIPING
D
2"
2"
N7
NOTE 8
2"-LUB-011525412-101SD0P-N
INST
3/4"
011-G-0041-A 1/2"
0750
PIPING
3/4"-LUB-011525415-101SD0P-N
1" 1"
LG
NC
N8
5
PZV 0752 1-1/2"x3/4"
NOTE 5 N12
NOTE 2 N11
NOTE 4 N1 N10 1" 6"
6
+
0751
4
TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
LUBE OIL RETURN FROM 011-G-0017B
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER 4 POTABLE WATER NOTES 5 DEMI WATER 1- THREE WAY TRANSFER VALVES. 6 N.A. 2- FILL STRAINER. 7 N.A. 3- LUBE OIL PURIFIER RETURN. 4- SPARE. 8 N.A. 5- AIR BREATHER. 9 HP STEAM 6- AT GRADE AT SAFE LOCATION. 10 MP STEAM 7- LUBE OIL SUCTION. 11 LP STEAM 8- EARTH. 12 HP CONDENSATE 9- HEATER WITH 480V AC, BPH, 60HZ. 13 MP CONDENSATE 10- HIGH TEMPERATURE CUTOUT AT 15.56°C (60°F). 11- OVER TEMPERATURE CUTOUT AT 85°C (185°F). 14 LP CONDENSATE 12- INSTRUMENT TUBING LINE. 15 BFW 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A.
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
01
14-JUL-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
00
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
PREPARED BY
CHECKED BY
REV
COMPANY STATUS
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PUMP AUXILIARY DETAILS FOR 011-G-0017A/B No 1
011-074 011-078 Item Tags :
011-075 011-080 011-077
011-S-0011 A/B, 011-E-0047 A/B, 011-F-0007, 011-D-0039, 011-G-0041 A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480260.pid
Discipline: PRO
SA-JER-DS011-TRJR-480260 2271-011-PID-0021-525
REV: 03
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
1-1/2"-LUB-011525401-101SD0P-N
37 36
37
ZC 0357
35
VAHH 0750 RA
IC 0750 VMS
32 31 30
35 34
ZAHH ZAHH 0770 AA 0770 AB
33 32
IC 0750
SI
VMS VMS
29
HH
28 6926
ZC 0357
VAHH 0770 RB
VMS
ZAHH ZAHH 0750 AA 0750 AB
36
VAHH 0770 RA
IC 0770
ZY 0751 A
HH 1-1/2" H VMS
TI 0750
H VMS
27
24 23 22 21
TE
TE
0750 B
0750 A
VT 0752 RX
HH
HH H VMS
TI 0753
HH
VY H 0753 R VMS
VY 0754 R
VT 0752 RY
TE 0752 A
TE 0752 B
TE 0753 A
19
OUTLET
1/2" NOTE 1
INLET
1/2" NOTE 1
ZT 0751 AB
HH
HH
VY
H 0755 R VMS
H VMS
TE 0753 B
ZY 0771 A
1-1/2"
1-1/2"
TE 0760 A
TE 0760 C
TE 0761 A
TE 0761 D
TE 0762 B
TE 0762 D
TE 0760 B
TE 0760 D
TE 0761 B
TE 0761 C
TE 0762 A
TE 0762 C
VT 0754 RY
+
+
18
HH H VMS
TI 0752
VMS
RO 0751 RO 0750
20
H VMS
0750 K
SI
VMS
HH 1-1/2" VY H 0772 R VMS LN08 1-1/2" TRJR CL150
TI 0770
H VMS
VENDOR
1-1/2"-LUB-011525403-101SD0P-N
25
VY 0752 R
MCC
31
LN08 TRJR
1-1/2" CL150
26
HH
IC 0770
1-1/2"-LUB-011525405-101SD0P-N
LUBE OIL SUPPLY FROM LUBE OIL SYSTEM
33
ZC 0357
VAHH 0750 RB
34
ZC 0357
RO 0752
RO 0753
+
TE
TE
0770 B
0770 A
HH H VMS
TI 0773
VT 0772 RX
VT 0772 RY
TE 0772 A
TE 0772 B
TE 0773 A
H 0775 R VMS
TE 0773 B
28
TE 0780 A
TE 0780 C
TE 0781 A
TE 0781 D
TE 0782 B
TE 0782 D
25
TE 0780 B
TE 0780 D
TE 0781 B
TE 0781 C
TE 0782 A
TE 0782 C
24 23 22
OUTLET
1/2" NOTE 1
INLET
1/2" VT 0755 RX
VY
H VMS
26
RO 0770 1/2" NOTE 1 1-1/2"
VY 0774 R
29
HH
27
+
1/2" NOTE 1 1-1/2"
VY H 0773 R VMS
VT 0774 RY
+
0754 RX ST 0750 K
HH H VMS
HH
VENDOR
+
VT 0753 RY
TI 0772
H VMS
HH
RO 0771
VT
VT 0753 RX
HH
30
MCC
0750 K
ZT 0771 AB
1-1/2"
1-1/2"
21
RO 0772
RO 0773
+
+
20
VT
VT 0773 RX
0774 RX
VT 0773 RY
19
1/2" NOTE 1 1-1/2"
ST 0770 K
1/2" NOTE 1 1-1/2"
VT 0775 RX
18 17
17
VT 16
ZT
3"
0751 AA 15
3"
3" 2"
TI
011-G-0017-A
0758
3"
VT ZT
0755 RY
0771 AA
011-GM-0017-A
TI
0778
TE 0751 B
TE 0751 A
12
TI
10
0751 9
TRJR HH H 3" VMS
TE 0754 A
TI 0767
TI 0768
TE 0755 A
TE 0771 B
TE 0755 B
LNOB
LNOB CL150 TI 0754
HH H VMS
TI 0755
HH H VMS
TI 0771 1"
TRJR HH H 3" VMS
011-SP-0761
TE 0774 B
TE 0774 A
TI 0787
TI 0788
TE 0775 A
TE 0775 B
13 12
3"-LUB-011525419-101SD0P-N
VENDOR
NOTE 3
15 14
011-SP-0759
TE 0771 A
3"-LUB-011525404-101SD0P-N
VENDOR 11
TE 0754 B
011-SP-0755
011-SP-0754
011-SP-0760
0779
011-SP-0758
13
16
0775 RY
011-GM-0017-B
TI
011-G-0017-B
14
3"
3"
3"
TI
011-SP-0757
011-SP-0756
0759
3"
NOTE 3 11
3" CL150 TI 0774
HH H VMS
TI 0775
HH H VMS
10
1"
9 8
8 7 6927
LUBE OIL RETURN TO LUBE OIL SYSTEM
6"x3"
7
3"-LUB-011525402-101SD0P-N 1"-IAI-011230310-301CG2P-N
6
1"-IAI-011230311-301CG2P-N
6
MCC
5
5
4
4
3
MHSS
MHSR
MHSS
MHSR
MHS
MHS
MHS
G0041 AL
G0041 AL
G0041 BL
G0041 BL
G0041 AL
G0041 BL
F0007 L
MAIN OIL PUMP MAIN OIL PUMP A STOP A START
2
3
MAIN OIL PUMP MAIN OIL PUMP MAIN OIL PUMP A MAIN OIL PUMP B OIL HEATER B STOP B START LOCAL/REMOTE LOCAL/REMOTE ON/OFF
2
ORIGINAL SIGNED IN PROJECT FILE
LOCAL PANEL TAG: 011-LP-G0017A/B MAIN PUMP A RUNNING
MAIN PUMP B RUNNING
MAIN OIL PUMP A RUNNING
AUX OIL PUMP B RUNNING
READY TO START MAIN PUMP A
MXL
MXL
MXL
MXL
XL
G0017 AL
G0017 BL
G0041 AL
G0041 BL
0750 L
1
NOTE 2
COMMON ALARM MAIN PUMP A
COMMON ALARM MAIN PUMP B
TRIP MAIN PUMP A
TRIP MAIN PUMP B
LAMP TEST
XL
UA
UA
UA
UA
HS
0770 L
0750 L
0770 L
0751 L
0771 L
0750 L
READY TO START MAIN PUMP B
1"-IAI-011230311-301CG2P-N
1
DCS
3"-IAI-011074301 DS011-TRJR-480213 10810
GENERAL NOTES
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER 4 POTABLE WATER NOTES 5 DEMI WATER 1- FOR PI CONNECTION. 6 N.A. 2- MONITORING SYSTEM WILL COMMUNICATE INDIVIDUALLY ALL INDICATIONS, ALARMS AND TRIP WITH THE DCS, ADDITIONALLY, A REDUNDANT COMMON TRIP 7 N.A. SIGNAL WILL BE WIRED TO THE ESD. 8 N.A. 3- INSTRUMENT AIR FOR ELECTRICAL PANEL 9 HP STEAM 10 MP STEAM 11 LP STEAM 12 HP CONDENSATE 13 MP CONDENSATE 14 LP CONDENSATE 15 BFW 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A. This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
01
14-JUL-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
00
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
AVS / MAC
JAL
PREPARED BY
CHECKED BY
REV
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PUMP AUXILIARY DETAILS FOR 011-G-0017A/B No 2
011-074 011-078 Item Tags :
011-075 011-080 011-077
011-G-0017-A/B, 011-GM-0017-A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480261 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480261 2271-011-PID-0021-525
REV: 03
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
41
40
011-D-0028 OIL RESERVIOR
39
011-S-0007-A / B LUBE OIL FILTERS
011-E-0043 OIL COOLERS
011-F-0003 OIL HEATER
40 39
38
38
37
ZC 0390
36
HH
TC 0557
H
UC 0553
37
H
36 35
TT 0558
34
TT
34
PCV 0565
0557
+
33
2"
32
2"
4"x2"
2"-PRO-011035409-101CS1P-N
NOTE 4 3/4" D 3/4"
VENDOR TRJR 31
PIPING INST.
TUBING NOTE 2
29
32
PI 0575
3/4"-PRO-011035403-101SD0P-N 28
3/4"-PRO-011035406-101SD0P-N
27
NC
011-S-0007-A
26
TUBING NOTE 13
29 28
3"
3/4"
3"
2"x1-1/2"
2"x1-1/2"
20 19
UC 0551
PI 0558
ZC 0390
PI 0559
LL
3/4"
PT 0559
3/4"
17
22
FC 3/4" D
21
3/4"
D
3/4"-PRO-011035422-101SD0P-N 20
NC PI
3"x2"
3"x2-1/2" 2-1/2"
1" 3/4"-OLW-011035309-101CS1P-N 2"-PRO-011035417-101SD0P-P
16
2" LO FB
1-1/2"F2" 8.20
NC
1-1/2"-PRO-011035418-101SD0P-P
14
TV 0557
LI 0551 0551
+
UC
NOTE 11
TT 0553
0555 6
V 2"
MF 0003
5
LT 0551
2"
3/4"
TP-6 2" CL150
4"
4"
TI 0554
2"
2"
2" 2" 3" 2"
2"
MCC
2
LUBE OIL FROM 011-K-0001
DS011-TRJR-480091 7986 LUBE OIL FROM 011-K-0001
DS011-TRJR-480091 7987
LUBE OIL
LUBE OIL
LUBE OIL
TO 011-K-0001
TO 011-K-0001
TO 011-KH-0001
FROM 011-K-0001
DS011-TRJR-480091 7991
DS011-TRJR-480091 7990
DS011-TRJR-480091 7988
DS011-TRJR-480091 7994
LUBE OIL TO 011-K-0001 DS011-TRJR-480091 7992
LUBE OIL
LUBE OIL
LUBE OIL
LUBE OIL
TO 011-K-0001
FROM 011-K-0001
FROM 011-KH-0001
DS011-TRJR-480091 7989
DS011-TRJR-480091 7995
DS011-TRJR-480091 7979
FROM 011-K-0001
DS011-TRJR-480091 7985
+
011-G-0029-B
2"-PRO-011035416-101SD0P-P
3/4"
PIPING INST
FC D 3/4"
3/4"
3/4"
2"
3"
D
OLW
V
2"
2"
2"-OLW-011035302-101CS1P-N
UC
MG
0551
0029 A
TYP 4
MCC
ZC 0390
OLW
NOTES
m³/h barg °C barg °C
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
8
MIN.
4"x3" 32
7
2655
3/4"
D 3"-CWR-011035301-101CS1P-N
6
TI 0559
V 3/4"
5
4"-CWS-011035303-101SD0P-N
4
2"
D
2"
4"x2"
2"
UC 0551
TP-8
MIN.
4"x3"
3"-CWS-011035306-101CS1P-N
2"-CWR-011035306-101CS1P-N
3 32 2654
3/4"
2
D
DUTY OIL PUMP
011-G-0029-A / B LUBE OIL PUMPS
4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
011-S-0007-A / B CARTRIDGE 19.8 5.50 60.00 10.00 120.00
2"
4"x2"
9
2"-CWR-011035308-101CS1P-N
D
SOFT CW
3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED.
FILTERS TYPE DES. CAPACITY OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP.
10
TRJR VENDOR
2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h PUMPS TYPE THROUGHPUT m³/h DISCH. PRESS. barg DIFF. PRESS. barg DES. PRESS. barg OP. TEMP. °C DENSITY AT COND. kg/m³
NOTE 8
NOTE 7
1
GENERAL NOTES
IN/OUT IN/OUT
11
FB LO
NOTE 3
2" CL150
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001).
SHELL/TUBE SHELL/TUBE
12
D
3/4"
SOFT CW
FROM 011-K-0001
TO 011-K-0001
03
13-MAR-2013
AB
DS011-TRJR-480091 7996
DS011-TRJR-480091 7993
02
30-SEP-2011
01 00
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
14-JUL-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
22-DEC-2010
AFC
NOT USED
VSC/ STG
AVS/ MAC
JAL
REV
011-E-0043 BEU 7.00 4.50 70.00 34.50 60.00 45.00 9.00 9.00 100.00 80.00 5.5 82.65 011-G-0029-A / B ROTARY SCREW 19.8 6.50 6.50 10.00 70.00 879.0
CL300
TP-9
ORIGINAL SIGNED IN PROJECT FILE
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
OLW
TI 0560
MCC
MG 0029 B
2"-CWR-011035307-101CS1P-N
3/4" FDP
011-E-0043
TYP 4
2"
14
NOTE 9
4"-CWR-011035305-101SD0P-N
3/4" 2"
+
2"x1"
PI
0390
15
TZV 0088
2"
2"
0555
2"
16
+
1"-CWS-011035307-101CS1P-N
2"-OLW-011035301-101CS1P-N
ZC 0390
PZV 0552
2"
M
TP-7
TYP 12
1
011-D-0028
011-F-0003
3"x2-1/2" 2-1/2"
TP-11
3
LG 0550
LO FB
1-1/2"-PRO-011035419-101SD0P-P
ZC
4
HE
3"-PRO-011035414-101SD0P-P
NOTE 1 TSHH
7
2"-PRO-011035413-101SD0P-P
RADAR 8
3"-PRO-011035412-101SD0P-P
L
2"-PRO-011035411-101SD0P-P
TI 0553
2"-PRO-011035410-101SD0P-P
UC 0552
2"-PRO-011035409-101CS1P-N
9
H
4"-PRO-011035408-101SD0P-N
NOTE 12
LO FB
0551
4"-PRO-011035407-101SD0P-N
10
1-1/2"F2" CL600 8.20
3/4"-PRO-011035405-101SD0P-N
11
L
NOTE 11
1"D2" 8.85
13
2"
2"-PRO-011035415-101SD0P-N
UC
12
CL600
LO FB
NOTE 5
+
PZV 0553 +
13
NC
+
17
MIN.
M
2"-PRO-011035420-101CS1P-N
15
19
+
18
INST PIPING 3/4" 2"
011-G-0029-A
TP-13
RO 0562
0556
INST PIPING
18
L
PT 0558
23
2"-PRO-011035410-101SD0P-P
INST PIPING
UC 0550
COMPRESSOR PERMISSIVE TO START
24
D
NOTE 6
NOTE 10 21
26
3"
3/4"
PCV 0560
3/4"-PRO-011035401-101SD0P-N
011-S-0007-B 25
D
+
22
27
V
NOTE 6
24
3/4"-PRO-011035423-101SD0P-N
3/4"
3"x2"
PDT 0557
3/4"-PRO-011035404-101SD0P-N
23
30
3/4" V 3"
25
1"
3/4"-OLW-011035303-101CS1P-N
30
2"
FO
2"x1-1/2"
TUBING NOTE 2
2"x1-1/2"
2"x1-1/2"
2"
4"x2" 31
33
INST PIPING
TRJR VENDOR
2"x1-1/2"
35
TI 0558
PDI 0557
1- LUBE OIL INITIAL FILL CONNECTION AND PURIFIER RETURN. 2- TUBING 1/2" ROTOR COOLING. 3- DRIP TRAY. 4- TEST POINT FOR VALVE CALIBRATION. 5- OIL SAMPLE POINT. 6- THREE WAY TRANSFER VALUE. 7- AT GRADE. AT SAFE LOCATION. 8- BLOCK VALUE SHALL BE INSTALLED WITH THE STEM IN OK BELOW THE HORIZONTAL POSITION. 9- SET PRESSURE READJUSTED BASED ON ELEVATION FROM PIPE TOP TO TZV ELEVATION DIFFERENCE SHOULD NOT BE HIGHER THAN 15m 10- LOP AUTO START LOGIC. 11- LOP PERMISSIVE TO START. 12- HEATER PERMISSIVE AND ON-OFF CONTROL. 13- TUBING 1/2" TIMING GEAR.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VDU OFF GAS COMPRESSOR - LUBE OIL SYSTEM
011-074 011-076 Item Tags :
011-075 011-080
011-G-0029 A/B, 011-D-0028, 011-S-0007 A/B, 011-F-0003, 011-E-0043
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480262 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480262 2271-011-PID-0021-035
REV: 03
Sheet: 3 of 4
SCALE: NONE Format:
A1
41
41
40
40
API PLAN 21/52 COOLING: K PUMP TYPE: BB2
39
39
38
38
37
37
36
36
35
35
34
H
PI
PI
XXXX (B)
33
29
(A)
33
TRJR VENDOR
PT XXXX
32
PT XXXX
PZV XXXX
PZV XXXX
PI XXXX
HPT
31
34
(B) XXXX
TRJR VENDOR
32
H
(A)
PI XXXX
HPT
RO XXXX
30
NOTE 2
TRJR VENDOR
29
31
29
RO XXXX
(A)
NOTE 4
30
(A)
NOTE 4
VENDOR
NOTE 2
TRJR
29
28
28
LPF (A)
LPF (D)
27
27
26
26
NOTE 1
NOTE 1
25 24
TRJR 23
LI 22
(A)
XXXX
H L
VENDOR
LG XXXX
(B)
LT XXXX
RO XXXX
TI XXXX
21
TRJR VENDOR
6
RO XXXX 1
7
D
3/4"
20
600RF 19
D NPT
011-SP-XXXX
VENDOR TRJR NOTE 3
011-SP-XXXX
(A)
22
L
18 17
2" 011-SP-XXXX
(B)
XXXX
21
6
D 011-SP-XXXX
LI (B)
(B)
23
H
3
VENDOR TRJR
15
TI XXXX
2
17 16
(D)
TRJR
LT XXXX
4 12
NPT
18
7
4 12
600RF 19
24
VENDOR
NOTE 3
(C)
3/4"
20
LG XXXX
25
(C)
16
011-SP-XXXX 011-SP-XXXX (D)
(F)
15
(E) VENDOR
14
14
OLW 13
CWS
13
32
12
12
CWR
32
11
11
10
10
9
9
8
8
7 6
011-RO-XXXX(A) 011-RO-XXXX(B) 011-PZV-XXXX(A) 011-PZV-XXXX(B) 011-LG-XXXX(A)
011-LG-XXXX(B)
011-LI-XXXX(A)
011-LI-XXXX(B)
011-LT-XXXX(A)
PUMP
TYPE
011-G-0012-A
BB2
RO-0870
RO-0871
PZV-0870
PZV-0871
LG-0870
LG-0872
LI-0871
LI-0873
LT-0871
011-G-0012-B
BB2
RO-0880
RO-0881
PZV-0880
PZV-0881
LG-0880
LG-0882
LI-0881
LI-0883
LT-0881
011-LT-XXXX(B)
011-PI-XXXX(A)
011-PI-XXXX(B)
011-PI-XXXX(C)
011-PI-XXXX(D)
011-PT-XXXX(A)
011-PT-XXXX(B)
LT-0873
PI-0870
PI-0871
PI-0872
PI-0873
PT-0871
PT-0873
LT-0883
PI-0880
PI-0881
PI-0882
PI-0883
PT-0881
PT-0883
7 6
5
5
011-RO-XXXX(C) 011-RO-XXXX(D) 011-SP-XXXX(A) 011-SP-XXXX(B)
011-TI-XXXX(A)
011-TI-XXXX(B)
CWS LINE No
CWR LINE No
LFL LINE (A)
LFL LINE (D)
OLW LINE No
SP-0877
TI-0873
TI-0874
2"-CWS-011171327-101CS1P-N
2"-CWR-011171327-101CS1P-N
3/4"-LFL-011171317-101CH2F-N
3/4"-LFL-011171319-101CH2F-N
SP-0887
TI-0883
TI-0884
2"-CWS-011171328-101CS1P-N
2"-CWR-011171328-101CS1P-N
3/4"-LFL-011171318-101CH2F-N
3/4"-LFL-011171320-101CH2F-N
011-SP-XXXX(C) 011-SP-XXXX(D)
4
PUMP
3
011-G-0012-A
RO-0872
RO-0873
SP-0870
SP-0875
SP-0872
011-G-0012-B
RO-0882
RO-0883
SP-0880
SP-0885
SP-0882
P&ID NUMBER
4
2"-OLW-011171317-101CS1P-N
SA-JER-DS011-TRJR-480065
3
2"-OLW-011171318-101CS1P-N
SA-JER-DS011-TRJR-480065
2
2
1
1
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS/ HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS/ MAC
JAL
01
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS/ MAC
JAL
00
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS/ MAC
JAL
PREPARED BY
CHECKED BY
REV
LEGEND 1
CASING VENT
2
PUMP DRAIN
3
BASE PLATE DRAIN
4
FLUSH SEAL CHAMBER INLET (FI)
5
FLUSH SEAL CHAMBER OUTLET (FO)
6
BARRIER / BUFFER FLUID SEAL CHAMBER INLET (LBI)
7
BARRIER / BUFFER FLUID SEAL CHAMBER OUTLET (LBO)
8
GAS BUFFER INLET (GBI)
9
CONTAINMENT SEAL VENT (CSV)
10 CONTAINMENT SEAL DRAIN (CSD) 11 SEAL QUENCH / DRAIN (D) 12 FROM PUMP DISCHARGE 13 TO PUMP SUCTION 14 BEARING HOUSING COOLING INLET. 15 BEARING HOUSING COOLING OUTLET. This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- BARRIER FLUID. FILLING CONNECTION. 2- MAKE CONNECTION ON TOP OF PIPE. 3- FOR DRAIN AND VENT DESTINATION AND DETAILS REFER TO PROCESS DRAWING. 4- RELIEF VALVE SHALL BE ROUTED TO DRAIN PAN.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY 011-078 011-074
PIPING AND INSTRUMENT DIAGRAM Project:
011-076 011-075 011-080
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PUMP AUXILIARY SEAL PLAN DETAILS No 11 ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480263.pid
Discipline: PRO
SA-JER-DS011-TRJR-480263 2271-011-PID-0021-171
REV:
03
Sheet: 11 of 11
SCALE: NONE Format:
A1
41
41
40
011-D-0029 OIL GAS SEPARATOR POT
39
40
011-D-0030 DRAIN POT
39
38
38
37
37
36
36
35
35
34
34
33
33
MECH SEAL
MECH SEAL
32
32 31
30
GAS SUCTION
29 28
GAS SUCTION (ON CASING) MIXED GAS RETURN (ON CASING)
31
30
PI 0567
GAS DISCHARGE
28
HIGH PRESSURE SELECTOR RELAY
PT
27 26
27
0567
R
PDI
29
L
R
0556
25
26
PCV 0569 +
HIGH PRESSURE SELECTOR RELAY
VENDOR
24
PCV 0568
1"-N2L-011035303-101CS1P-N
25
V
2"x1"
TP-16 1" CL150
+
23
3/4"
TRJR
2"-N2L-011035301-101CS1P-N
24
27 4090
MIN.
23
22
22
21
21
LI 0554
19
HPT 29
18
TRJR
6769
NOTE 1
17
VENDOR TP-17
1"-LFL-011035305-101CH2F-N
19
INSTRUMENT AIR
2"-IAI-011035301-301CG2P-N
DS011-TRJR-480213 11730
18
LT 0554
TUBING
17
RADAR
LO
16
20
H TUBING
20
1"
1"
2"
PIPING INST.
15
3/4"
V
16
PIPING INST.
15
2"
14
14
LG 0553
13 12
13
GLASS 12
2"
11
1"
10
011-D-0029
HPT 29
9
TRJR
6770
INST. PIPING
10 9
VENDOR LO
1"-LFL-011035306-101CH2F-N
TUBING
TP-18
8
TUBING
NC
7
3/4" D
3/4"
NOTE 1
8
11
PIPING INST.
3/4" 1"
1"
6
PIPING INST.
7
V PIPING INST.
6
2" 5
5
LG 0552 GLASS
4
4
2"
3
3
PIPING INST.
2
TRJR 1"-CLD-011035302-101CH2S-N
1
1"
VENDOR TP-19
011-D-0030
TUBING
3/4"
D
2
INST. PIPING
ORIGINAL SIGNED IN PROJECT FILE
1
3/4" 2"x1" 250mm MIN.
MIN.
2"-CLD-011035302-101CH2S-N
25 6771
GENERAL NOTES 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES 1- CONNECT ON TOP OF PIPE.
mm mm barg °C barg °C
011-D-0029
011-D-0030
600.0 305.0 2.50 122.00 12.00 170.00
600.0 305.0 2.50 122.00 12.00 170.00
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
13-MAR-2013
AB
AB:AS BUILT
MJR / STG
AVS / MAC
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
01
14-JUL-2011
AFC
AFD: APPROVED FOR CONSTRUCTION
JGT/STG
AVS / MAC
JAL
00
22-DEC-2010
AFC
NOT USED
VSC/ STG
AVS/ MAC
JAL
PREPARED BY
CHECKED BY
REV
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001).
DRUM TYPE HEIGHT DIAMETER OP. PRESS. OP. TEMP. DES.PRESS. DES.TEMP.
03
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 011-K-0001 SHAFT SEAL ARRANGEMENT
011-074 011-076 Item Tags :
011-075 011-080
011-D-0029, 011-D-0030
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480264.pid
Discipline: PRO
SA-JER-DS011-TRJR-480264 2271-011-PID-0021-035
REV:
03
Sheet: 4 of 4
SCALE: NONE Format:
A1
41
41
011-KM-0001 MAIN DRIVE MOTOR
40
011-KH-0001 GEAR BOX
011-K-0001 VDU OFF GAS COMPRESSOR
011-K-0004-A / B NOISE HOOD FANS
011-KM-0004-A / B NOISE HOOD FAN MOTORS
40
39
39
38
38
37
37
H
TI
36
0565
H
VI
0555 RY MMS
MMS
H
VI
H
TI
0558 RX MMS
0566
H
SI
36
0553 K
MMS
MMS
35
35
TI
34
0585
H
H
VI
0555 RX MMS
MMS
H
VI
H
VI
0557 S MMS
H
TI
0558 RY MMS
0586
34
MMS
33
33
32
32
31 30
VT
VT
VT
VT
ST
0555 RX
0555 RY
0558 RX
0558 RY
0553 K
TE
TE
VE
VE
VT
VE
VE VT
TE
TE
SE
0585
0565
0555 RX
0555 RY
0557 S
0558 RX
0550 RY 0558 RX
0566
0586
0553 K
RTD
RTD
29
RTD
31 30
RTD
29
28
28
HH H
VI 0560 SA MMS
27
HH H
TYPICAL 4
VI 0560 SB MMS
26
0553
24
GAS
GTI
MCC
23
H
TI 0564
22
TI 0561
21 20
UC 0550
19
TE 0561
18
16
26
UC
25
17
27
ZC
MK
K0001 AL
0390
0001
TI 0567
VT 0560 SA
MMS
VT 0560 SB
TE 0571 A
TE 0572 A
TE 0573 A
TE 0571 B
TE 0572 B
TE 0573 B
TI 0562
TE 0569 RTD
TE 0567
H TE 0564
MMS
ZE 0555 A
TE 0562
NOTE 2
ZT
TYPICAL 6
14
COMPRESSOR PERMISIVE TO START
ZE 0556 A
011-K-0001
0551
RTD
MCC
FGS
GDT 0312
011-KM-0004-A
ZT 0555 A
TI 0569
H
TLI 0516
H FGS
TDL 0516
MK
ZC
0004 A
0390
23 22 21
MCC
MMS
20
H ZI 0555 A MMS
UC 0553
19 18
RTD
ZE
15
H
24
011-K-0004-A
HEAT THRUST BEARING
MMS
RTD MHSX
MMS
H
H
CTI 0312
25
ZE 0552
011-KM-0001 011-KH-0001
13
ZT 0556 A THRUST BEARING
0551 A
TE 0570 RTD
HEAT TDL 0515
ZT 0552 A
12
H
ZI 0556 A MMS
MK
ZC
0004 B
0390
17 16 15
TI 0570
H
MCC
14
MMS
H
TLI 0515
13
011-KM-0004-B
FGS
12
GAS H
ZI
11
GDT 0311
0552 A MMS
10
H
GTI 0311
011-K-0004-B
FGS
11 10
H
ZI 0551 A MMS
9
9
8
8
7
7
RTD 6 5 4
RTD
RTD
RTD
SE
TE
TE
VT
VT
VT
VT
VT
TE
TE
0550 K
0583
0563
0550 RX
0550 RY
0552 S
0553 RX
0553 RY
0568
0588
ST
VE
VE
VE
VE
0550 K
0550 RX
0550 RY
0553 RX
0553 RY
6 5 4
3
3
2
TI 0583
1
SI 0550 K
H MMS
H
VI
H
VI
0550 RX MMS
MMS
TI 0563
H
VI
0552 S MMS
VI
H
0550 RY MMS
MMS
H
H
TI
0553 RY MMS
VI
H
0553 RX MMS
0588
TI 0568
2
H MMS
1
H MMS
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
01
14-JUL-2011
AFC
AFC : APPROVED FOR CONSTRUCTION
JGT / STG
AVS/ MAC
JAL
00
22-DEC-2010
AFC
NOT USED
VSC/ STG
AVS/ MAC
JAL
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001).
UTILITIES IDENTIFICATION POS.
1 2 3 4 5 NOTES 6 1- STANDARD HOWDEN VENTILATION SYSTEM. 7 2- SAFE LOCATION ACTUATING BUTTON SHALL INSTALLED AT GRADE AND LOCATED MORE THAN 15 M FROM ANY FIRE-HAZARDOUS EQUIPMENT,ALSO AT LEAST 7.5 M 8 BEYOND THE EDGE OF ANY FIRE HAZARDOUS ZONE. 9 10 11 12 13 14 15 16 17 18
2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 011-K-0001 CONDITION MONITORING
011-074 011-076 Item Tags :
011-075 011-080
011-K-0001, 011-KM-0001, 011-KH-0001, 011-K-0004 A/B, 011-KM-0004 A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480265 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480265 2271-011-PID-0021-401
REV: 03
Sheet: 1 of 1
SCALE: NONE Format:
A1
41
41
40
40
LOCAL CONTROL PANEL SIGNALS 011-LP-K0001
39
39
38
38
37
37
36
36
35
35
OIL PUMP 'A' CONTROL 011-G-0029-A
34 33 32
OIL PUMP 'B' CONTROL 011-G-0029-B
ACOUSTIC VENT FAN 'A' 011-K-0004-A
ACOUSTIC VENT FAN 'B' 011-K-0004-B
34
LOCAL REMOTE
START
RUNNING INDICATOR
LOCAL REMOTE
START
RUNNING INDICATOR
LOCAL REMOTE
START
RUNNING INDICATOR
LOCAL REMOTE
START
RUNNING INDICATOR
MHS
MHSR
MXL
MHS
MHSR
MXL
MHS
MHSR
MXL
MHS
MHSR
MXL
G0029 AL
G0029 AL STOP G0029 AL
31
G0029 BL
G0029 BL STOP G0029 BL
K0004 AL
K0004 AL STOP K0004 AL
K0004 BL
33
K0004 BL STOP K0004 BL
MHSS
MHSS
MHSS
MHSS
G0029 AL
G0029 BL
K0004 AL
K0004 BL
32 31
30
30
29
MXS
MXS
MXS
MXS
G0029 A
G0029 B
K0004 A
K0004 B
29
28
28
27
27
26
ZC
MCC
ZC
MCC
0390
ZC
MCC
0390
ZC
MCC
0390
26
0390
25
25
24
24
23
M
M
M
23
M
22
22
21
21
20
20
19
19
18
18
17
17
16
16
15
HEATER CONTROL 011-F-0003
14 13 12
15
MAIN DRIVE MOTOR 011-K-0001
ON/OFF
RUNNING INDICATOR
LOCAL REMOTE
STOP
RUNNING INDICATOR
HORN ACKNOWLEDGE
COMMON ALARM
MHSR
MXL
MHS
MHSS
MXL
HS
UA
F0003 L
F0003 L
K0001 L
K0001 L
K0001 L
0555 L
0550 L
HORN ALARM
COMMON TRIP
LAMP TEST
PERMISSIVE TO START
EMERGENCY STOP
UA
UA
HS
XL
MHSX
0555 L
0551 L
0550 L
0550 L
K0001 BL
14 13 12
02 11
11
10
10
MXS F0003
9
MXS K0001
9
8
8
7
7
6
MCC
ZC 0390
MCC
ZC 0390
DCS
ZC 0390
6
5
5
4
4
3
M
3
M
2
2
1
1
ORIGINAL SIGNED IN PROJECT FILE
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
01
14-JUL-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT/STG
AVS/ MAC
JAL
00
22-DEC-2010
AFC
NOT USED
VSC/ STG
AVS/ MAC
JAL
PREPARED BY
CHECKED BY
REV
GENERAL NOTES
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 1 FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER 4 POTABLE WATER NOTES 5 DEMI WATER 6 N.A. 7 N.A. 8 N.A. 9 HP STEAM 10 MP STEAM 11 LP STEAM 12 HP CONDENSATE 13 MP CONDENSATE 14 LP CONDENSATE 15 BFW 16 PLANT AIR 17 INSTRUMENT AIR 18 N.A. This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 011-K-0001 LOCAL CONTROL PANEL SIGNALS
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480266 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480266 2271-011-PID-0021-402
REV: 03
Sheet: 1 of 1
SCALE: NONE Format:
A1
41
41
011-S-0012-A / B TWIN FILTERS
011-F-0008 ELECTRICAL HEATER
011-D-0035 OIL TANK
40
011-E-0048-A / B LUBE OIL COOLER
40
39
39
1"-LUB-011405401-101SD0P-N
38
LUBE OIL 38 TO 011-K-0003 7981
37
37
PDT 0484
36
VENDOR
TRJR
35
ZC 0331
VENDOR
TRJR
PI 0481
34
PI 0482 LL
NOTE 11
UC 0323
L
3/4"
V
32
INST PIPING
31
PI
PT
PT
PT
PT
0480
0481 A
0481 B
0481 C
0482
3/4"
3/4"
3/4"
3/4"
INST PIPING
30
1"-LUB-011405401-101SD0P-N
NOTE 13
3/4"
3/4"
29
3/4"
D
3/4"
+
3/4"
34 33
3/4"
PCV 0483
35
H
PDI 0484
011-S-0012-A
33
36
VENDOR TRJR
32
INST PIPING
31
NOTE 13
NOTE 8
FO
28
3/4"
V
3/4"
2"
TI 0488
+
1"-LUB-011405404-101SD0P-N
25
3/4"
D
3/4"
1"
MCC
3/4"
21
MHSS
MHSR
MHSS
MHSR
MHS
MHS
MHS
20
G0042 AL
G0042 AL
G0042 BL
G0042 BL
G0042 AL
G0042 BL
F0008 L
19
MAIN OIL PUMP A STOP
MAIN OIL PUMP A START
MAIN OIL PUMP A LOCAL / REMOTE
MAIN OIL PUMP B START
UC
MAIN OIL PUMP B LOCAL / REMOTE
MXL G0042 AL
MXL G0042 BL
FAN RUNNING
MAIN OIL PUMP A RUNNING
MAIN OIL PUMP B RUNNING
14
XL 0480 L
UA 0480 L
NOTE 13 NOTE 8
FAN COMMMON ALARM
FAN READY TO START
HS 0480 L
INST PIPING
LAMP TEST
FAN TRIP
INST
3/4"
PI 0487
0491
1"-LUB-011405403-101SD0P-N
011-LP-K0003 LOCAL PANEL
12 11 10
MG 0042 A
1-1/2" M
TYP.4
TRJR
VENDOR
MF 0008
NOTE 5 NOTE 10 NOTE 4 K1 1"
NOTE 3 B1 A1 1" 3"
ON/OFF 2
MCC
NOTE 6 TYP.11
TRJR
3/4"
1"
VENDOR
NOTE 7 TSHH
TSH/L
0484
0485
1-1/2"-OLW-011405302-101CS1P-N
NC
2"
19
TZV 0497
17
1"-CWR-011405306-101CS1P-N
+
16
NOTE 12 3/4"
14
V
2"
1"
VENDOR
1"
1"-CWS-011405302-101CS1P-N
PUMPS TYPE THROUGHPUT DISCH. PRESS. DIFF. PRESS. DES. PRESS. OP. TEMP. DENSITY AT COND.
m³/h barg barg barg °C kg/m³
011-G-0042-A / B SCREW 1.0 5.40 7.00 9.00 60.00 888.0 NOTE 15
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
13
1"-CWS-011405301-101CS1P-N
32
12
D
11 10
LUBE OIL FROM 011-R-00037982
1" 1"
1" 1-1/2"
011-G-0042-B M
VENDOR
MCC
TRJR
TYP.4 PCV 0486 +
1/2"-LUB-011405409-101SD0P-N 1-1/2"
NOTE 9
011-F-0008
2"
0480
2"
5 4
1/2"
1/2"
1/2"
3
2
ORIGINAL SIGNED IN PROJECT FILE 1
TI 0493
N1
NC
8
6
FC
2"
0481
9
7
LT
LG
1-1/2" VENDOR
011-D-0035
TI 0496
LI 0481
GENERAL NOTES
DES.PRESS. barg SHELL/TUBE DES.TEMP. °C SHELL/TUBE SURFACE m² DUTY Gcal/h TANK TYPE HEIGHT mm DIAMETER mm OP. PRESS. barg OP. TEMP. °C DES.PRESS. barg DES.TEMP. °C
TRJR
4"x1"
8122
H L
TRJR TI 0496
H L
UC 0324
UC 0324
011-G-0042-A / B OIL PUMPS
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
01
14-JUL-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS/ MAC
JAL
00
22-DEC-2010
AFC
NOT USED
VSC/ STG
AVS/ MAC
JAL
PREPARED BY
CHECKED BY
REV
IN/OUT IN/OUT
4"x1"
2"
OLW
SHELL/TUBE SHELL/TUBE
15
TI 0492
3/4"
D
18
+
MG 0042 B
VENDOR TRJR
011-E-0048-A / B TEMA C 5.00 4.30 61.00 35.00 46.00 38.00 9.00 9.00 80.00 80.00 3.7 8.00 011-D-0035 RECTANGULAR 450.0 NOTE 14 0.02 65.00 ATM 80.00
23
20
NC
C1
M1
EXCHANGERS TEMA TYPE OP. PRESS. barg OP. TEMP. °C
32 8121
1/2"
D11"
1-1/2"
1-1/2"
1"-LUB-011405407-101CS1P-N 1"-LUB-011405408-101CS1P-N
MCC
HOLD
1"-CWR-011405301-101CS1P-N
PI 0497
011-G-0042-A
3
24
TRJR
4"x1"
PIPING INST.
1"
4
1"-CWR-011405302-101CS1P-N
3%
7
5
VENDOR
4"x1"
D
011-E-0048-B
+
1"
1"
1"
PZV 0490
+
1"
3"-LUB-011405402-101SD0P-N
8
6
V
+
PZV 0489
1-1/2"-LUB-011405405-101CS1P-N
9
3/4"
1"X1" 6.00
+
13
3/4"
0488 1"X1" 6.00
2"
. 1"D1"
PIPING
PI
OLW
NOTE 13
+
UA 0481 L
26
TI
+
1/2"-LUB-011405409-101SD0P-N
MXL K003 L
27
21
RO 0481
1-1/2"-LUB-011405406-101CS1P-N
15
1
V
3/4"
17 16
L
22
1"
D
1"-LUB-011405403-101SD0P-N
OIL HEATER ON / OFF
UC 0332
1"
1"-CWR-011405305-101CS1P-N
18
MAIN OIL PUMP B STOP
2"
28
H
TI 0489
NOTE 16
3/4"
011-E-0048-A
22
TT 0489
25
V
23
TRJR
TCV 0490
NOTE 12 1"-CWR-011405303-101CS1P-N
011-S-0012-B 24
VENDOR
4"x1"
4"x1"
NC
26
TZV 0498
1"-CWR-011405304-101CS1P-N
2mm
29
NOTE 2
+
+
27
3/4"-OLW-011405301-101CS1P-N
NC
1"D1"
.
RO 0480
30
NOTE 1
1"x3/4"
POS. DESCRIPTION 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 1 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. FIRE WATER 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 2 SERVICE WATER 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED. 3 COOLING WATER 4 POTABLE WATER NOTES 5 DEMI WATER 1- OIL SAMPLE PICK UP LINE. 6 N.A. 2- SCREWED PLUG. 7 N.A. 3- FILLING CONNECTION. 4- INSPECTION DOOR. 8 N.A. 5- TANK BREATHER (DIAMETER 0.5" ) 9 HP STEAM 6- FROM OIL CONDITIONER. 10 MP STEAM 7- TO OIL CONDITIONER. 11 LP STEAM 8- MECHANICAL LINK. 12 HP CONDENSATE 9- HEATER WITH 1KW, 480V AC, 60HZ, 3PH. 13 MP CONDENSATE 10- SPARE 14 LP CONDENSATE 11- ALARM / STRAT-UP OF AUXILIARY PUMP (SET=0.10 barg) 12- AT GRADE AT SAFE LOCATION. 15 BFW 13- THREE WAY TRANSFER VALVE. 16 PLANT AIR 14- WIDTH = 540 mm. LENGTH = 990 mm. 17 INSTRUMENT AIR 15- DENSITY AT 15 ºC. 18 N.A. 16- CONTROL FAIL BYPASS.
COMPANY STATUS
DATE
UTILITIES IDENTIFICATION REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 011-K-0003 AUXILIARY DETAILS No 1
011-074 011-076 Item Tags :
011-075 011-080
011-S-0012 A/B, 011-E-0048 A/B, 011-F-0008, 011-G-0042 A/B, 011-D-0035
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480267 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480267 2271-011-PID-0021-405
REV: 03
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
40
LUBE OIL 7981 FROM 011-S-0010 A/B 39
40
011-KM-0003 ELECTRICAL MOTOR
1"-LUB-011405401-101SD0P-N
39
38
38
37
37
36
36
35
35
34
34
33
33
32
32
31
31
30
30
29
29
ZC 0331
E SLOP
28
MK 0003
28
27
27
26
26
1"
1"
25
25
MXX TRIP/STOP SIGNAL
MCC
24
1"x3/4"
24
TYP.3
1"x3/4"
23
G
22
23
TRJR VENDOR
G
22
21
21
20
20
19 18
19
I
I
011-K-0003
18
011-KM-0003
H
15 14 13 12
VENDOR TRJR VENDOR TRJR 2"x1-1/2"
17
H VENDOR TRJR 2"x1-1/2"
16
J
2"x1-1/2"
J
1-1/2"-OLW-011405307-101CS1P-N
17
1-1/2"-OLW-011405303-101CS1P-N
TT
TT
0481
0482
TE 0485 A
TE 0486 A
TE 0487 A
TE 0485 B
TE 0486 B
TE 0487 B
15 14 13
TE
TE
TE
0485 C
0486 C
0487 C
TE
TE
TE
0485 D
0486 D
0487 D
12
1-1/2"-OLW-011405304-101CS1P-N
TT
11
16
11
0480
8
LUBE OIL 7982 TO 011-D-0035
3% MIN.
10
FDP
VENDOR TRJR
9
TRJR VENDOR
10
9 8
7
7
VENDOR TRJR
6
6
5
TI 0480
HH H
TI 0481
HH H
TI 0482
HH H
5
4
4
4"x1-1/2" 3
TI
4"x1-1/2" ZC
2"
0331
0483
2
2
4"x1-1/2"
011-SP-0480
3"-LUB-011405402-101SD0P-N
TI 0484
4"x1-1/2"
1
3
2"
1
011-SP-0481
3"x1-1/2"
011-K-0003 FLUE GAS INDUCED FAN
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
01
14-JUL-2011
AFC
AFC: AFC APPROVED FOR CONSTRUCTION
JGT / STG
AVS/ MAC
JAL
00
22-DEC-2010
AFC
NOT USED
VSC/ STG
AVS/ MAC
JAL
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PRECEDED BY 011 (EX. 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 011-K-0003 AUXILIARY DETAILS No 2
011-074 011-076 011-075 011-080
Item Tags :
011-K-0003, 011-KM-0003
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480268.pid
Discipline: PRO
SA-JER-DS011-TRJR-480268 2271-011-PID-0021-405
REV:
03
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
PY 0160 C
40
NOTE 5
39
PLC 0160 C
02
40
NOTES 2, 3, 8
PLS 0160 CC
PV 0160 C
41
011-K-0002-A/ B/ C COMBUSTION AIR FORCED FANS
39
+
38
8127 AIR 011-S-0013 A/B/C
AIR DUCT
FO NOTE 4
NOTE 9
37
NOTE 6 NOTE 1
36
PI 0387
35 34
HH H
TI 0385
33
37
1/2"
UC 0331
36
38
HH H
TI 0386
35 34
HH H
TI 0387
33
32
32
MK 0002 C
31
ZC 0331
31
NOTE 7
30
30
TYP.4 29 28
TT
TT
0385
0386
0387
29
PLC
MCC
TT
0160 B 28
27
27
26
011-K-0002-C
26
011-KM-0002-C
25
25
1-1/2" TE 0388 B
24
NOTE 6
23
TE 0388 A
1-1/2"-OLW-011403303-101CS1P-N
TE 0389 B TE 0390 A
TE 0389 A
24
TE 0390 B
23
PY 0160 B
22
22
DIRECTLY WIRED ON MOTOR WINDING BY MANUFACTURER
21
21
NOTE 1 NOTE 3
AIR DUCT
OLW
PLC
NOTE 5
PY 19
PLS 0160 CB
0160 A
0160 A
PLS
18
0160 CA
PV 0160 A
NOTE 6
NOTE 6
AIR DUCT FO NOTE 4
NOTE 1
NOTE 9
UC 15 14
0391
HH H
TI 0392
FO NOTE 4
NOTE 1
16 15 14
NOTE 1 TI
17
UC 0331
0331
13
18
+
17
NOTE 9
19
PV 0160 B
+
16
20
HH H
TI 0393
NOTE 1
HH H
TI 0400
12
MK
NOTE 6
11
TI 0401
H
HH H
TI 0402
1-1/2"-IAI-011403301-301CG2P-N
HH
13
H 12
MK
ZC
0002 B
0331
ZC
0002 A
10
HH
NOTE 6
0331
11
NOTE 7
9
TYP.4
TYP.4 TT
8
0392
TT
MCC TT 0402
0393
TT 0391
7
TT
TT
0401
0400
MCC
6
011-K-0002-A
011-KM-0002-A
10
1-1/2"-IAI-011403301-301CG2P-N
20
9 8 7 6
011-K-0002-B
5
5
1-1/2"-OLW-011403301-101CS1P-N
3 2 1
SIGNAL
011-KM-0002-B
1-1/2"
1-1/2"
4
TE 0394 A
TE
TE
0394 B
0395 B
TE 0395 A
TE TE 0396 A
1-1/2"-OLW-011403302-101CS1P-N
0396 B
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- SUPPLIER TO VERIFY FULL COMPLIANCE WITH JERES J-603. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES
88000.0 0.00 45.00
NOTE 10
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
TE
3
0397 A
TE 0397 B
TE 0398 B
4
AIR
2
TO 011-E-0041
1
DIRECTLY WIRED ON MOTOR WINDING BY MANUFACTURER
GENERAL NOTES
barg °C barg °C
0398 A
DS011-TRJR-480121 8129
8130
011-K-0002-A / B / C
0399 A
OLW
DS011-TRJR-480121
BLOWERS TYPE FLOW OP. PRESS. OP. TEMP. DES. PRESS. DES. TEMP.
TE
TE 0399 B
OLW
011-PC-0160
TE
INSTRUMENT AIR FROM HOOD OF 8145 CARTRIDGE FILTER
1- TIGH SHUT-OFF PLATE. 2- FOR PROCESS CONNECTION REFER TO DWG: SA-JER-DS011-TRJR-480121. 3- AIR DUCT CONNECTED TO PREHEATER 011-E-0041 REFER TO SA-JER-DS011-TRJR-480121. 4- INLET DAMPERS. PROVIDED BY VENDOR. 5- 2 OFF CABLES INTEGRAL WITH LIMIT SWITCHES. 6- FLEXIBLE JOINT. 7- FOR CABLE TYPE AND POSITION REFER TO VENDOR DWG: SA-JER-DS011-DSBS-270377. 8- FANS: 2 OPERATING + 1 SPARE. 9- DAMPER POSITION TO BE FORCED TO 0% IF ID FAN IS OFF. 10- UNITS IN Kg/h.
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
01
14-JUL-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JMV / STG
AVS / MAC
JAL
00
22-DEC-2010
AFC
NOT USED
VSC/ STG
AVS/ MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 011-K-0002 AND AIR FILTERS AUXILIARY DETAILS No 1
011-074 011-076 Item Tags :
011-075 011-080
011-K-0002 A/B/C, 011-KM-0002 A/B/C
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480269 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480269 2271-011-PID-0021-403
REV: 03
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
011-S-0013 - A/ B/ C/ D CARTRIDGE FILTER
40
40
39
39
38 8127 AIR
38
AIR DUCT
TO 011-K-0002A/B/C 37
37
36
36
35
35
34
34
33
33
32
32
31
31
30
30
29 28 27
FAILURE
CLEANNING
START
XA 0385
XL 0386
XL 0387
PDT
PDI
0394
0394
H
29
START
CLEANNING
XL 0390
XL 0389
FAILURE
28
XA 0388
27
26
26
25
25
24
24
011-LP-S0013-2
011-LP-S0013-1
HS 0390
23 22
NOTE 2
23
PS
PS 0460
0461
21
22
NOTE 2
21
ID
20
20
PI
19
PI
011-S-0013-B CARTRIDGE FILTER (2nd module)
0388
011-S-0013-D CARTRIDGE FILTER (4th module)
0389
19
18
18
XYV 0364
XYV 0363
XYV 0362
S
XYV 0365
S
S
S
XYV 0366
S
XYV 0367
XYV 0368
S
XYV 0369
S
XYV 0370
S
XYV 0371
S
XYV 0372
XYV 0373
S
XYV 0374
S
S
S
XYV 0375
S
XYV 0376
S
XYV 0377
XYV 0378
S
S
S
XYV 0379
XYV 0380
XYV 0340
S
S
XYV 0339
S
XYV 0338
XYV 0337
S
S
XYV 0336
XYV 0335
S
S
XYV 0334
XYV 0333
S
S
XYV 0332
XYV 0331
S
S
XYV 0330
S
XYV 0329
XYV 0328
S
S
XYV 0327
S
XYV 0326
S
XYV 0325
S
XYV 0324
XYV 0323
S
S
XYV 0322
S
XYV 0321
S
S
17
17
XYV 0361
16
16
JS-305
JS-306
JS-307
NOTE 1
JS-308
JS-316
JS-315
JS-314
JS-313
15
15
14
14
13
13
SANDY AIR INLET
SANDY AIR INLET
SANDY AIR INLET
SANDY AIR INLET
12
12
11
11
PI 10
PI
011-S-0013-A CARTRIDGE FILTER (1st module)
0391
011-S-0013-C CARTRIDGE FILTER (3rd module)
0392
10
9
9
XYV 0359
XYV 0358
S
XYV 0357
XYV 0356
S
S
XYV 0355
S
XYV 0354
S
XYV 0353
S
XYV 0352
S
XYV 0351
S
XYV 0350
S
XYV 0349
XYV 0348
S
XYV 0347
S
S
S
XYV 0346
S
XYV 0345
S
XYV 0344
XYV 0343
S
S
XYV 0342
S
XYV 0341
XYV 0301
S
XYV 0302
S
XYV 0303
S
XYV 0304
S
XYV 0305
S
XYV 0306
S
XYV 0307
S
XYV 0308
S
XYV 0309
S
XYV 0310
S
XYV 0311
S
XYV 0312
S
XYV 0313
S
S
XYV 0314
S
XYV 0315
S
XYV 0316
S
XYV 0317
S
XYV 0318
S
XYV 0319
S
XYV 0320
S
S
8
8
XYV 0360
7
7
JS-301
JS-302
JS-303
JS-304
JS-312
JS-311
JS-310
JS-309
6
6
5
5
4
INSTRUMENT AIR 8145 TO PV-0160 A/B/C
SANDY AIR INLET
SANDY AIR INLET
4
SANDY AIR INLET
1-1/2"-IAI-011403301-301CG2P-N
3
3
TRJR
2 7753
1
SANDY AIR INLET
AT 0040
17
2"-IAI-011403301-301CG2P-N
AI 0040
VENDOR
2"x1-1/2"
HC
HC
NOTE 4
AT
AT
0045 A
0045 B
2 1
NOTE 3
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- HOOD OF CARTRIDGE FILTER 2- ELECTRONIC TIMER & LOCATED AT 011-LP-S0013 3- AMBIENT GAS DETECTOR INSTALLED AT SANDY AIR INLET. 4- LOCATED BELOW AIR FILTER INLET.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
H
ZC
ZC
0334
0335
ZC
ZC
AI
AY
AI
0330
0331
0045
0045
0045 C
2oo2
HH
H
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
01
14-JUL-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS/ MAC
JAL
00
22-DEC-2010
AFC
NOT USED
VSC/ STG
AVS/ MAC
JAL
REV
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 011-K-0002 AND AIR FILTERS AUXILIARY DETAILS No 2
011-074 011-076 Item Tags :
011-075 011-080
ORIGINAL SIGNED IN PROJECT FILE
011-S-0013 A/B/C/D
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480270 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480270 2271-011-PID-0021-403
REV: 03
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
41
40
40
39
39
38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20
PUMPS
011-TE-XXXX-A
011-TE-XXXX-B
011-TE-XXXX-C
011-G-0005-A
TE-0950
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
011-G-0005-B
TE-0955
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
011-G-0007-A
TE-0802-A
TE-0803-A
TE-0804-A
TE-0802-B
TE-0803-B
TE-0804-B
TE-0802-C
TE-0803-C
TE-0804-C
TE-0802-D
TE-0803-D
011-G-0007-B
TE-0812-A
TE-0813-A
TE-0814-A
TE-0812-B
TE-0813-B
TE-0814-B
TE-0812-C
TE-0813-C
TE-0814-C
TE-0812-D
TE-0813-D
011-G-0008-A
TE-0850
TE-0851
TE-0852
NA
NA
NA
NA
NA
NA
NA
NA
011-G-0008-B
TE-0860
TE-0861
TE-0862
NA
NA
NA
NA
NA
NA
NA
011-G-0010-A
TE-0792-A
TE-0793-A
TE-0794-A
TE-0792-B
TE-0793-B
TE-0794-B
NA
NA
NA
011-G-0010-B
TE-0797-A
TE-0798-A
TE-0799-A
TE-0797-B
TE-0798-B
TE-0799-B
NA
NA
011-G-0011-A
TE-0511-A
TE-0512-A
TE-0513-A
TE-0511-B
TE-0512-B
TE-0513-B
NA
011-G-0011-B
TE-0516-A
TE-0517-A
TE-0518-A
TE-0516-B
TE-0517-B
TE-0518-B
011-G-0012-A
TE-0870
TE-0871
TE-0872
NA
NA
011-G-0012-B
TE-0880
TE-0881
TE-0882
NA
NA
011-G-0013-A
TE-0521-A
TE-0522-A
TE-0523-A
TE-0521-B
TE-0522-B
011-G-0013-B
TE-0526-A
TE-0527-A
TE-0528-A
TE-0526-B
TE-0527-B
011-G-0014-A
TE-0890
TE-0891
TE-0892
NA
NA
011-G-0014-B
TE-0900
TE-0901
TE-0902
NA
011-G-0015-A
TE-0910
TE-0911
TE-0912
011-G-0015-B
TE-0920
TE-0921
TE-0922
011-G-0016-A
TE-0960
NA
011-G-0016-B
TE-0965
NA
011-G-0018-A
TE-0930-A
011-G-0018-B
011-VT-XXXX-A
NA
NA
NA
NA
NA
NA
NA
NA
DS011-TRJR-480047
NA
NA
NA
NA
NA
NA
NA
NA
NA
DS011-TRJR-480047
TE-0804-D
VE-0800-S
VE-0801-S
VE-0802-S
VT-0800-S
VT-0801-S
VT-0802-S
VI-0800-S
VI-0801-S
VI-0802-S
DS011-TRJR-480051
TE-0814-D
VE-0810-S
VE-0811-S
VE-0812-S
VT-0810-S
VT-0811-S
VT-0812-S
VI-0810-S
VI-0811-S
VI-0812-S
DS011-TRJR-480051
NA
VE-0850-S
VE-0851-S
VE-0852-S
VT-0850-S
VT-0851-S
VT-0852-S
VI-0850-S
VI-0851-S
VI-0852-S
DS011-TRJR-480063
NA
NA
VE-0860-S
VE-0861-S
VE-0862-S
VT-0860-S
VT-0861-S
VT-0862-S
VI-0860-S
VI-0861-S
VI-0862-S
DS011-TRJR-480063
NA
NA
NA
VE-0790-S
VE-0791-S
VE-0792-S
VT-0790-S
VT-0791-S
VT-0792-S
VI-0790-S
VI-0791-S
VI-0792-S
DS011-TRJR-480064
NA
NA
NA
NA
VE-0795-S
VE-0796-S
VE-0797-S
VT-0795-S
VT-0796-S
VT-0797-S
VI-0795-S
VI-0796-S
VI-0797-S
DS011-TRJR-480064
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
DS011-TRJR-480055
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
DS011-TRJR-480055
NA
NA
NA
NA
NA
NA
NA
VE-0870-S
VE-0871-S
VE-0872-S
VT-0870-S
VT-0871-S
VT-0872-S
VI-0870-S
VI-0871-S
VI-0872-S
DS011-TRJR-480065
NA
NA
NA
NA
NA
NA
NA
VE-0880-S
VE-0881-S
VE-0882-S
VT-0880-S
VT-0881-S
VT-0882-S
VI-0880-S
VI-0881-S
VI-0882-S
DS011-TRJR-480065
TE-0523-B
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
DS011-TRJR-480057
TE-0528-B
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
DS011-TRJR-480057
NA
NA
NA
NA
NA
NA
NA
VE-0890-S
VE-0891-S
VE-0892-S
VT-0890-S
VT-0891-S
VT-0892-S
VI-0890-S
VI-0891-S
VI-0892-S
DS011-TRJR-480066
NA
NA
NA
NA
NA
NA
NA
NA
VE-0900-S
VE-0901-S
VE-0902-S
VT-0900-S
VT-0901-S
VT-0902-S
VI-0900-S
VI-0901-S
VI-0902-S
DS011-TRJR-480066
NA
NA
NA
NA
NA
NA
NA
NA
NA
VE-0910-S
VE-0911-S
VE-0912-S
VT-0910-S
VT-0911-S
VT-0912-S
VI-0910-S
VI-0911-S
VI-0912-S
DS011-TRJR-480096
NA
NA
NA
NA
NA
NA
NA
NA
NA
VE-0920-S
VE-0921-S
VE-0922-S
VT-0920-S
VT-0921-S
VT-0922-S
VI-0920-S
VI-0921-S
VI-0922-S
DS011-TRJR-480096
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
VE-0960-S
NA
NA
VT-0960-S
NA
NA
VI-0960-S
NA
NA
DS011-TRJR-480099
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
VE-0965-S
NA
NA
VT-0965-S
NA
NA
VI-0965-S
NA
NA
DS011-TRJR-480099
TE-0931-A
TE-0932-A
TE-0930-B
TE-0931-B
TE-0932-B
NA
NA
NA
NA
NA
NA
VE-0930-S
VE-0931-S
VE-0932-S
VT-0930-S
VT-0931-S
VT-0932-S
VI-0930-S
VI-0931-S
VI-0932-S
DS011-TRJR-480103
TE-0940-A
TE-0941-A
TE-0942-A
TE-0940-B
TE-0941-B
TE-0942-B
NA
NA
NA
NA
NA
NA
VE-0940-S
VE-0941-S
VE-0942-S
VT-0940-S
VT-0941-S
VT-0942-S
VI-0940-S
VI-0941-S
VI-0942-S
DS011-TRJR-480103
011-G-0021-A
TE-0530-A
TE-0531-A
TE-0532-A
TE-0530-B
TE-0531-B
TE-0532-B
NA
NA
NA
NA
NA
NA
VE-0530-S
VE-0531-S
VE-0532-S
VT-0530-S
VT-0531-S
VT-0532-S
VI-0530-S
VI-0531-S
VI-0532-S
DS011-TRJR-480111
011-G-0021-B
TE-0535-A
TE-0536-A
TE-0537-A
TE-0535-B
TE-0536-B
TE-0537-B
NA
NA
NA
NA
NA
NA
VE-0535-S
VE-0536-S
VE-0537-S
VT-0535-S
VT-0536-S
VT-0537-S
VI-0535-S
VI-0536-S
VI-0537-S
DS011-TRJR-480111
011-G-0022-A
TE-0980
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
DS011-TRJR-480124
011-G-0022-B
TE-0985
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
DS011-TRJR-480124
TE-0642-A
TE-0640-B
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
DS011-TRJR-480232
TE-0640-A
TE-0641-A
011-TE-XXXX-E
TE-0641-B
011-TE-XXXX-F
011-TE-XXXX-G
011-VE-XXXX-C
011-G-0025
011-TE-XXXX-D
TE-0642-B
011-TE-XXXX-H
011-TE-XXXX-I
011-TE-XXXX-J
011-TE-XXXX-K
011-TE-XXXX-L
011-VE-XXXX-A
011-VE-XXXX-B
011-VT-XXXX-B
011-VT-XXXX-C
011-VI-XXXX-A
011-VI-XXXX-B
011-VI-XXXX-C
P&DS NUMBER
011-G-0026-A
TE-0990
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
DS011-TRJR-480219
011-G-0026-B
TE-0995
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
DS011-TRJR-480219
38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20
19
19
18
18
17
17
16
16
15
15
TE XXXX
14
(J) 13
TE XXXX
12
TE XXXX
U VI
7 6 5 4 3
(F)
(E)
V
12
NOTE 1
11
TE XXXX (B)
W
10
(C)
TRJR VENDOR
9 8
TE XXXX
TE XXXX (A)
13
(I)
(H) TE XXXX
TE XXXX
10
TE XXXX
TE XXXX
(D)
14
(L)
(K)
(G)
11
TE XXXX
TE XXXX
XXXX
(E)
9
VT
VE
XXXX
XXXX
(C)
COUPLING
MAIN DRIVE MOTOR
8
(C)
DMS
VI
7
HH
TRJR VENDOR VT
XXXX
XXXX
VI
VT
(B) DMS
XXXX (A) DMS
XXXX
6
VE (B)
XXXX
(B)
5 4
VE (A)
XXXX (A)
2
3 2
ORIGINAL SIGNED IN PROJECT FILE
1
1
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
01
14-JUL-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
00
22-DEC-2010
AFC
NOT USED
VSC/ STG
AVS / MAC
JAL
PREPARED BY
CHECKED BY
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- THESE INSTRUMENTS TAGS ARE RELATED TO MCC NOT TO DCS.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PUMP AUXILIARY SIGNALS AND ALARMS DETAILS No 1
011-074 011-076 Item Tags :
011-075 011-080
011-G-0005 A/B, 011-G-0007 A/B, 011-G-0008 A/B, 011-G-0010 A/B, 011-G-0011 A/B, 011-G-0012 A/B, 011-G-0013 A/B, 011-G-0014 A/B, 011-G-0015 A/B, 011-G-0016 A/B, 011-G-0018 A/B, 011-G-0021 A/B, 011-G-0022 A/B, 011-G-0025, 011-G-0026 A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480271 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480271 2271-011-PID-0021-172
REV: 03
Sheet: 1 of 2
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
37
36
36
35
35
34
34
33
33
32
32
31
31
30
30
29
29
TI
28
H 28
XXXX 27
27
TRJR VENDOR
26
26
TT XXXX
25
25
24
24
23
23
22
22
1
21
21
2 NOTES 1,2
20
VENDOR
3
TRJR
20
VENDOR LT XXXX
TRJR
19
LI
19
XXXX
NOTES 1,2
18
18
17
17
16
16
15
15
PZE
14
14
VENDOR 13
13
TRJR NOTE 1
12
12
11
11
10
10
9
9
8
PUMPS
7 6 5 4
011-TT-XXXX
011-TI-XXXX
011-LT-XXXX
011-LI-XXXX
8
P&ID NUMBER
011-G-0006-A
TT-0820
TI-0820
LT-0820
LI-0820
DS011-TRJR-480114
011-G-0006-B
TT-0825
TI-0825
LT-0825
LI-0825
DS011-TRJR-480114
011-G-0019-A
TT-0830
TI-0830
LT-0830
LI-0830
DS011-TRJR-480088
011-G-0019-B
TT-0835
TI-0835
LT-0835
LI-0835
DS011-TRJR-480088
011-G-0023-A
TT-0840
TI-0840
LT-0840
LI-0840
DS011-TRJR-480095
011-G-0023-B
TT-0845
TI-0845
LT-0845
LI-0845
DS011-TRJR-480095
7 6 5 4
3
3
2
2
1
1
03
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS/ HCR
JAL
02
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
01
14-JUL-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
00
22-DEC-2010
AFC
NOT USED
VSC/ STG
AVS/ MAC
JAL
PREPARED BY
CHECKED BY
APPR/AUTH BY
REV
LEGEND 1
COUPLING HOUSING DRAIN
2
PUMP DRAIN
3
BASE PLATE DRAIN
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- FOR DRAINS DESTINATION AND DETAILS REFER TO PROCESS DRAWINGS. 2- CASING DRAIN FITTED COMPLETE WITH GATE VALVE AND BLIND FLANGE BY VENDOR, REFER TO PROCESS DRAWING.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
COMPANY STATUS
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 PUMP AUXILIARY SIGNALS AND ALARMS DETAILS No 2
011-074 011-076 Item Tags :
011-075 011-080
011-G-0006 A/B, 011-G-0019 A/B, 011-G-0023 A/B
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480272 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480272 2271-011-PID-0021-172
REV: 03
Sheet: 2 of 2
SCALE: NONE Format:
A1
41
41
TYPE 15 SPECIAL SAMPLE CONNECTION HIGH TEMPERATURE LIQUID SAMPLE REHEATED OR COOLED (TEMP > 65ºC)
40
TYPE 4 CLOSED SAMPLE CONNECTION (FOR GAS SERVICE)
40
39
39
38
38
NOTE 8
SOURCE OF DIFFER. PRESS. NOTE 3
36
FLO SPEC
MIN.
NOTES 7,12 MIN.
FLO
NOTE 10
32
NOTES 7,12 2"x3/4" NOTE 11
BREAK FLANGE NOTES 7,12 SOURCE OF DIFFER. PRESS. NOTE 3
NOTE 11
2"x3/4"
35
33
MIN. 3/4"
34
PROCESS LINE
MIN.
33
36
3/4"
PROCESS SPEC
34
3/4"
MIN.
35
37
HOT LIQUID LINE MIN.
MIN.
37
D
3/4"
NOTES 7,12
32
BREAK FLANGE
31
31
3/4"
30
30
29
29
VENDOR
28
NOTE 5
3"x3/4"
24
1/2"x1/4" SWAGE
OVERFLOW
NOTE 1
29
VENDOR TRJR
TRJR
3/4"
VENDOR
24
3/4" 23
NOTES 7,12
2
20
PROCESS PIPING CLASS DRAIN PIPING CLASS
2"
3/4"
21
25
NOTE 4
2"x3/4" 22
26
HPT
1/2" 3/4"x1/2"
3/4"x1/2" RED. CPLG.
1/4" NIPPLE NOTE 9
23
1/2"
D
LFL PIPING CLASS
3"x3/4"
3/4"x1/2"
3/4" MIN.
25
27
PROCESS PIPING CLASS
26
28
PI
TW
27
TRJR
22 21 20
OLW 25
19
19
18
18
17
17
16 15
SC
INLET LINE
011-SC-0023
3/4"-HFO-011040114-103CS1P-S
011-SC-0043
1"-HFO-011027110-103CL4P-S
OUTLET LINE
3/4"-HFO-011040113-103CS1P-S 1"-HFO-011027111-103CL4P-S
SAMPLE COOLER OULTET LINE
SERVICE WATER INLET LINE
OVERFLOW LINE
3/4"-HFO-011200101-103CS1P-N
3/4"-RWA-011200309-301CG0W-N
1"-OLW-011200309-101CS1P-N
2"-CLD-011200325-101CH2S-N
3/4"-FLO-011200302-101CS1P-N
011-TW-0247
DS011-TRJR-480104
1"-HFO-011200102-103CL4P-N
3/4"-RWA-011200313-301CG0W-N
1"-OLW-011200313-101CS1P-N
2"-CLD-011200326-101CH2S-N
3/4"-FLO-011200303-101CS1P-N
011-TW-0248
DS011-TRJR-480066
CLD OUTLET LINE
TW
FLUSHING INLET LINE
P&ID NUMBER
16
SC
011-SC-0030
INLET LINE
OUTLET LINE
1"-GAS-011036012-101CH4S-S
1"-GAS-011036013-101CH4S-S
FLARE OUTLET LINE
ALTERNATIVE CLOSED DRAIN
PI
1"-LFL-011200310-101CH2F-N
NA
011-PI-0489
P&ID NUMBER 15
DS011-TRJR-480094
14
14
13
13
TYPE 1 GENERAL SAMPLE FOR LIQUID SERVICE (NOT FOR DANGEROUS LIQUID SERVICE)
12
12 11
10
10
9 8 7
PROCESS LIQUID LINE NOTE 8
9
MIN.
11
8
NOTE 12
7
3/4"- VALVE ACCORDING TO PROCESS LINE PIPING CLASS 600#
6 5
3/4"-NEEDLE VALVE
4
6 5
VENDOR TRJR
4
3/4"x1/2" 1/2"-BALL VALVE
3
3
NOTE 1 SO 1/2" F.N.P.T
2
2
1
1
SC
INLET LINE
P&ID NUMBER
011-SC-0001
3/4"-CRU-011001020-106CS1P-N
DS011-TRJR-480002
011-SC-0005
1"-BRN-011042004-101CS4P-N
DS011-TRJR-480109
011-SC-0014
3/4"-PRW-011043012-106CS2P-N
DS011-TRJR-480110
011-SC-0047
2"-CWR-011072301-301FE0W-N
DS011-TRJR-480207
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- LOCATE SAMPLE OUTLET ACCESSIBLE FROM GRADE OR SERVICE PLATFORM. 2- TO BE USED ONLY FOR SAMPLE THAT ARE VERY RARELY USED WHEN CONNECTION TO FLARE IS DIFFICULT TO BE DONE. 3- ANY CONVENIENTLY LOCATED SOURCE OF DIFFERENTIAL PRESSURE, CONTROL VALVE, HEAT EXCHANGERS, ETC. 4- THREADED FEMALE CONNECTION FOR SAMPLE CYLINDER. 5- MANOMETER SHALL BE LOCATED FOR READING BY PERSON OPERATING NEEDLE VALVE (ON CYLINDER). 6- DELETED. 7- USE DOUBLE BLOCK WHERE REQUIRED IN JERES C-102. 8- TAKE SAMPLE CONNECTION FROM LATERAL SIDE. 9- BEVEL ALL OPEN ENDS OF SIMPLE CONNECTIONS AT 45 ANGLE WITH 75mm MINIMUM EXTENSION. 10- USE FLUSHING OIL AFTER SAMPLING HEAVY LIQUID. 11- IF REQUIRED. USE REDUCER IF BLOCK VALVES ARE NOT 3/4" SIZE. 12- 1" MINIMUM SIZE FOR 6.0 mm CORROSION ALLOWANCE MATERIAL SPECIFICATION.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
04
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS/ HCR
JAL
03
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS / MAC
JAL
01
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
00
24-SEP-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 SAMPLE DETAILS No 1
011-078 Item Tags :
011-075 011-080 011-077
ORIGINAL SIGNED IN PROJECT FILE
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480273.pid
Discipline: PRO
SA-JER-DS011-TRJR-480273 2271-011-PID-0021-200
REV:
04
Sheet: 1 of 3
SCALE: NONE Format:
A1
TYPE 7 SAMPLE COOLER MAIN LINE (NOTE 9)
41 40 39
41
TYPE 5 CLOSED SAMPLE CONNECTION (FOR LIQUID SERVICE)
40 39
NOTE 15 NOTES 22, 23
38
MIN. 3/4"
37
NOTE 4
PURGE MEDIUM (IF REQUIRED)
37
36
SOURCE OF DIFFER. PRESS. NOTE 2
MIN.
NOTE 15
35
VENDOR
TW
33
TRJR
2"x3/4"
ALTERNATIVE
3/4"
VALVE ACCORDING TO PROCESS LINE PIPING CLASS
3/4"
TO PROCESS
34
36
PROCESS LINE
MIN.
3/4"
MIN.
MIN.
38
35
3/4" 2"x3/4"
NOTE 22
34
NOTE 22
33
MIN.
3/4"
32
32
SO 1"-OVERFLOW
30
31
NOTE 5 3/4"
NOTE 12
2"x3/4"
29
30
3/4"x1/2"
3/4"
27
2" PROCESS PIPING CLASS CLD PIPING CLASS
250 mm MIN.
2 28
NOTE 17 25
OLW
SP
VENDOR
TRJR
1/2"
VENDOR ALTERNATIVE
SC
INLET LINE
SERVICE WATER INLET LINE
PROCESS LINE TO CLOSED DRAIN
ALTERNATIVE OUTLET LINE
24
011-SC-0008
3/4"-HFO-011038017-103CS1P-S
3/4"-RWA-011200301-301CG0W-N
NA
3/4"-HFO-011038018-103CS1P-S
011-SC-0009
3/4"-CLD-011006304-103CS1P-H
3/4"-RWA-011200302-301CG0W-N
NA
3/4"-CLD-011006305-103CS1P-P
011-SC-0010
3/4"-CLD-011007306-103CS1P-H
3/4"-RWA-011200303-301CG0W-N
NA
011-SC-0015
3/4"-CRU-011006007-103CS1P-H
3/4"-RWA-011200304-301CG0W-N
011-SC-0016
3/4"-CRU-011007005-103CS1P-H
011-SC-0017 011-SC-0018
23 22 21 20 19 18 17 16 15
SAMPLE COOLER OUTLET LINE
OVERFLOW LINE
1"-OLW-011200301-101CS1P-N
28
NOTE 1
27
SO
PURGE LINE
TW
P&ID NUMBER
OLW
3/4"-HFO-011200103-103CS1P-N
3/4"-LPS-011200301-101CS1P-H
011-TW-0250
DS011-TRJR-480100
NOTE 18
1/2"-CLD-011200313-103CS1P-N
NA
011-TW-0252
DS011-TRJR-480011
NOTES 20,21
3/4"-CLD-011007314-103CS1P-P
NOTE 19
1/2"-CLD-011200314-103CS1P-N
NA
011-TW-0255
DS011-TRJR-480012
NOTES 20,21
NA
3/4"-CRU-011006010-103CS1P-P
NOTE 18
1/2"-CRU-011200001-103CS1P-N
NA
011-TW-0256
DS011-TRJR-480011
NOTES 20,21
3/4"-RWA-011200305-301CG0W-N
NA
3/4"-CRU-011007010-103CS1P-P
NOTE 19
1/2"-CRU-011200002-103CS1P-N
NA
011-TW-0257
DS011-TRJR-480012
NOTES 20,21
1"-BRN-011006004-103CS4P-P
3/4"-RWA-011200306-301CG0W-N
1"-BRN-011200003-103CS4P-N
2"-CLD-011200315-101CH2S-N
1"-OLW-011200306-101CS1P-N
1"-BRN-011200001-103CS4P-N
NA
011-TW-0259
DS011-TRJR-480011
NOTES 20,21
3/4"-BRN-011007009-106CS2P-H
3/4"-RWA-011200307-301CG0W-N
3/4"-BRN-011200004-106CS2P-N
2"-CLD-011200316-101CH2S-N
1"-OLW-011200307-101CS1P-N
3/4"-BRN-011200002-106CS2P-N
NA
011-TW-0261
DS011-TRJR-480013
3/4"-BDH-011200001-101CS1P-N
NA
011-TW-0267
DS011-TRJR-480105
NOTE 5
3/4" MIN.
26 25
29
TRJR
3/4"
NOTE 12
26
MIN.
3/4" MIN.
25
2"x3/4" PROCESS PIPING CLASS ALTERNATIVE PIPING CLASS
250 mm MIN.
3"X1/2"
MIN.
31
24 23 22
25
21 20
011-SC-0022
3/4"-BDH-011040003-101CS1P-P
3/4"-RWA-011200308-301CG0W-N
3/4"-BDH-011200002-101CS1P-N
2"-CLD-011200317-101CH2S-P
1"-OLW-011200308-101CS1P-N
011-SC-0024
3/4"-LPS-011040015-101CS1P-H
3/4"-RWA-011200310-301CG0W-N
3/4"-LPS-011200002-101CS1P-N
2"-CLD-011200318-101CH2S-P
1"-OLW-011200310-101CS1P-N
3/4"-LPS-011200001-101CS1P-N
NA
011-TW-0268
DS011-TRJR-480105
011-SC-0046
3/4"-HFO-011038011-103CL2P-S
3/4"-RWA-011200315-301CG0W-N
NA
3/4"-HFO-011038009-103CL2P-S
1"-OLW-011200315-101CS1P-N
3/4"-HFO-011200002-103CL2P-N
3/4"-LPS-011200303-101CS1P-H
011-TW-0277
DS011-TRJR-480099
011-SC-0049
3/4"-BFW-011071304-101CS1P-H
3/4"-RWA-011200317-301CG0W-N
3/4"-BFW-011200302-101CS1P-N
2"-CLD-011200321-101CH2S-P
1"-OLW-011200317-101CS1P-N
3/4"-BFW-011200301-101CS1P-N
NA
011-TW-0290
DS011-TRJR-480202
011-SC-0061
3/4"-CRU-011006011-103CS1P-H
3/4"-RWA-011200318-301CG0W-N
NA
3/4"-CRU-011006012-103CS1P-P
NOTE 18
1/2"-CRU-011200003-103CS1P-N
NA
011-TW-0291
DS011-TRJR-480011
NOTE 20
011-SC-0002 3/4"-DIE-011037014-103CS1P-N
3/4"-DIE-011037015-103CS1P-N
3/4"-DIE-011200001-103CS1P-N
2"-CLD-011200301-101CH2S-P
1/2"-OLW-011200330-103CS1P-N
011-SC-0062
3/4"-CRU-011007017-103CS1P-H
3/4"-RWA-011200320-301CG0W-N
NA
3/4"-CRU-011007018-103CS1P-P
NOTE 19
1/2"-CRU-011200004-103CS1P-N
NA
011-TW-0333
DS011-TRJR-480012
NOTE 20
011-SC-0003 3/4"-DIE-011025006-103CS1P-N
3/4"-DIE-011025007-103CS1P-N
3/4"-DIE-011200002-103CS1P-N
2"-CLD-011200302-101CH2S-P
011-SC-0063
3/4"-PRW-011052019-101CS2P-P
3/4"-RWA-011200325-301CG0W-N
NA
3/4"-PRW-011052020-101CS2P-P
1"-OLW-011200325-101CS1P-N
3/4"-PRW-011200001-101CH2S-N
NA
011-TW-0336
DS011-TRJR-480124
011-SC-0019 3/4"-JET-011025009-103CS1P-N
3/4"-JET-011025010-103CS1P-N
3/4"-JET-011200001-103CS1P-N
011-SC-0050
3/4"-CND-011071307-103CS1P-H
3/4"-RWA-011200322-301CG0W-N
3/4"-CND-011200302-103CS1P-N
1"-OLW-011200326-101CS1P-N
1"-OLW-011200322-101CS1P-N
3/4"-CND-011200301-103CS1P-N
NA
011-TW-0372
DS011-TRJR-480201
011-SC-0020 3/4"-HFO-011025007-103CS1P-N
3/4"-HFO-011025008-103CS1P-N
3/4"-HFO-011200003-103CS1P-N
19
SC
NOTE 17
PROCESS LINE TO CLOSED DRAIN
OUTLET LINE
INLET LINE
ALTERNATIVE OUTLET LINE
P&ID NUMBER
18
011-SP-0019
DS011-TRJR-480098
17
1/2"-OLW-011200331-103CS1P-N
011-SP-0020
DS011-TRJR-480060
2"-CLD-011200306-101CH2S-N
1/2"-OLW-011200332-103CS1P-N
011-SP-0006
DS011-TRJR-480058
2"-CLD-011200307-101CH2S-P
1/2"-OLW-011200333-103CS1P-N
011-SP-0007
DS011-TRJR-480062
OLW LINE
SP
16 15
14
14
TYPE 8 SPECIAL SAMPLE CONNECTION (FOR GAS SERVICE) PROCESS LINE
TYPE 13
13 12
2"x3/4"
SPECIAL SAMPLE CONNECTION HIGH TEMPERATURE GAS AND FLASHING LIQUID SAMPLE SERVICE (TEMP > 65ºC)
NOTE 22
NOTE 10
3/4"
MIN.
11 10
3/4"
NOTES 5, 11,16
12
MIN. NOTES 3,11
11
NOTE 22
10
HOT GAS LINE
NOTE 10
9
13
PI
9
NOTE 6
3/4" x 1/2"
8
8
HPT 3/4"
7
7
1/2"
29
NOTE 13 TW
PI
5
3"x3/4"
NOTE 14 3"x3/4" 3/4"
NOTE 22
3/4"
NC
4
3/4" D 3
1/2"
2
VENDOR NOTE 8
1/2"X1/4" SWAGE NIPPLE
1/2"X1/4"
VENDOR
TRJR
NOTE 7
5
NOTE 8
4 3
SC
1/2"
011-SC-0012
SWAGE NIPPLE
NOTE 1
1
TRJR
6
NOTE 8
MIN.
PROCESS PIPING CLASS LFL PIPING CLASS
6
OUTLET LINE
FLARE OUTLET LINE
PI
P&ID NUMBER
3/4"-FGS-011200301-101CS2P-S
3/4"-LFL-011200305-101CH2F-N
011-PI-0492
DS011-TRJR-480214
INLET LINE
3/4"-FGS-011075311-101CS2P-S
2 1
HPT
2
29
3/4" 3/4" x 1/2"
NOTE 13
3/4"
OLW
MIN.
SC
011-SC-0025
FLARE OUTLET LINE
SAMPLE COOLER OUTLET LINE
3/4"-LFL-011200303-101CH2F-N
3/4"-GAS-011200002-101CH4S-P
INLET LINE
1"-GAS-011035008-101CH4S-P
SERVICE WATER INLET LINE
1"-RWA-011200323-301CG0W-N
OVERFLOW LINE
PI
TW
P&ID NUMBER
1"-OLW-011200323-101CS1P-N
011-PI-0491
011-TW-0497
DS011-TRJR-480091
011-TW-0338
DS011-TRJR-480135
011-TW-0339
DS011-TRJR-480023
011-SC-0039
3/4"-NAP-011098005-103CH2S-P
3/4"-LFL-011200309-101CH2F-N
3/4"-NAP-011200001-103CH2S-N
3/4"-RWA-011200319-301CG0W-N
1"-OLW-011200319-101CS1P-N
011-PI-0498
011-SC-0040
3/4"-NAP-011012011-101CH2S-P
3/4"-LFL-011200304-101CH2F-N
3/4"-NAP-011200002-101CH2S-P
3/4"-RWA-011200326-301CG0W-N
1"-OLW-011200327-101CS1P-N
011-PI-0499
3/4" 3/4"
D
PROCESS PIPING CLASS FLARE PIPING CLASS
NC
04
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
03
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS / MAC
JAL
01
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS / MAC
JAL
00
24-SEP-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IRG / STG
AVS / MAC
JAL
PREPARED BY
CHECKED BY
REV
NOTES 17- SAMPLE SC-0050 TO BE DRAINED TO OLW. 18- SAMPLE OUTLET OVERFLOW TO BE SENT TO A COMMON DRAIN SUMP. 4"DRAIN OUTLET TO BE ROUTED TO OILY WATER SEWER BY LINE 4"-OLW-011200328-101CS1P-N. 19- SAMPLE OUTLET OVERFLOW TO BE SENT TO A COMMON DRAIN SUMP. 4"DRAIN OUTLET TO BE ROUTED TO OILY WATER SEWER BY LINE 4"-OLW-011200329-101CS1P-N. 20- SAMPLE COOLER AND DRAIN SUMP TO BE SUPPLIED BY DESALTER VENDOR AS LOOSE ITEMS. 21- FOR SAMPLE DETAILS REFER TO VENDOR PID SA-JER-DS011-DJAR-210033. 22- IF REQUIRED USE REDUCER IF BLOCK VALVES ARE NOT 3/4". 23- TAKE CONNECTION ON TOP OF PIPE IN LINE LPS.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- LOCATE SAMPLE OUTLET ACCESSIBLE FROM GRADE OR SERVICE PLATFORM. 2- ANY CONVENIENTLY LOCATED SOURCE OF DIFFERENTIAL PRESSURE, CONTROL VALVE, HEAT EXCHANGERS, ETC. 3- VALVE ACCORDING TO THE PROCESS LINE PIPING CLASS. 4- LOCATE VALVE IN ACCESSIBLE POSITION. 5- USE BOUBLE BLOCK WHERE REQUIRED IN JERES-C-102. 6- MANOMETER SHALL BE LOCATED FOR READING BY PERSON OPERATING NEEDLE VALVE (ON CYLINDER). 7- PROVIDE ADEQUATE SPACE FOR REMOVABLE SAMPLE CYLINDER. 8- THREADED FEMALE CONNECTION FOR SAMPLE CYLINDER. 9- TO BE SPECIFIED FOR PROCESS TEMPERATURE > 65ºC. 10- TAKES SAMPLE CONNECTION FROM TOP OF HORIZONTAL LINE. 11- VALVE ACCORDING TO THE PROCESS LINE PIPING CLASS. 12- USE BLIND FLANGE INSTEAD OF PLUG WHEN DOUBLE VALVE IS REQUIRED AS PER DRAIN AND VENTS ARRANGEMENT IN JERES C-103. 13- MAKE CONNECTION ON TOP OF PIPE. 14- FLANGE RATING CL 300. 15- TAKE SAMPLE CONNECTION FROM LATERAL SIDE. 16- MINIMUM VALVE SIZE WILL BE 1" TO PIPING SPECIFICATION 101CH4S.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 SAMPLE DETAILS No 2 ORIGINAL SIGNED IN PROJECT FILE
Item Tags :
011-075 011-080
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480274 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480274 2271-011-PID-0021-200
REV: 04
Sheet: 2 of 3
SCALE: NONE Format:
A1
41 40
41
TYPE 24 SPECIAL SAMPLE CONNECTION HIGH TEMPERATURE GAS AND FLASHING LIQUID SAMPLE SERVICE (TEMP > 65ºC)
TYPE 14 SPECIAL SAMPLE CONNECTION HIGH TEMPERATURE GAS AND FLASHING LIQUID SAMPLE SERVICE (TEMP>65ºC).
40
39
39
NOTE 9
3/4"
36
MIN.
SOURCE OF DIFFER. PRESS. NOTE 4
3/4" NOTE 11
2"x3/4"
SOURCE OF DIFFER. PRESS. NOTE 4
3/4"
NOTE 1
35
HOT LIQUID LINE
MIN.
MIN.
37
38
NOTE 9
HOT LIQUID LINE
2"x3/4"
37
MIN.
38
36
3/4"
NOTE 1
35
NOTE 11
34
34
33
HPT
PI
33
PI
29 32
32
TW
TW
3"x3/4"
3/4"x1/2" RED. CPLG.
1/2" 28
OVERFLOW
3/4" D
VENDOR TRJR NOTE 6
1/2"x1/4"
NC
1/2"
RED. CPLG.
3/4"x1/2"
29
3/4"
NOTE 8
3"x3/4"
PROCESS PIPING CLASS LFL PIPING CLASS
3"x3/4"
30
31
3"x3/4"
3/4"x1/2"
1/2"
30
3/4"x1/2" RED. CPLG.
1/2" OVERFLOW
1/2"x1/4"
NOTE 6
2
28 27
SWAGE NIPPLE
PROCESS PIPING CLASS AMD PIPING CLASS
2" 2
3/4"
NOTE 8
2"x3/4"
26 25
3/4" D
1/2"x1/4"
NOTE 5
SWAGE NIPPLE
29
NOTE 1
VENDOR TRJR MIN.
1/2"x1/4"
SWAGE NIPPLE
NOTE 5
3/4"x1/2"
RED. CPLG.
27
SWAGE NIPPLE
3/4"
3/4"
MIN.
NOTE 1
3/4"
250mm MIN.
31
26 25
AMD 24
24
OLW
OLW
23
23
22 21 20
SC
OUTLET LINE
INLET LINE
011-SC-0006 3/4"-NAP-011019019-101CH2S-P
FLARE OUTLET LINE
3/4"-NAP-011019020-101CH2S-P
3/4"-LFL-011200306-101CH2F-N
SAMPLE COOLER OUTLET LINE
SERVICE WATER INLET LINE
OVERFLOW LINE
3/4"-RWA-011200324-301CG0W-N 3/4"-NAP-011200003-101CH2S-N
PI
1"-OLW-011200324-101CS1P-N
011-PI-0416
TW
P&ID NUMBER
011-TW-0365
DS011-TRJR-480047
011-SC-0027 3/4"-CWS-011012002-101CH2S-P
3/4"-CWS-011012003-101CH2S-P
3/4"-LFL-011200307-101CH2F-N
3/4"-RWA-011200311-301CG0W-N
3/4"-CWS-011200001-101CH2S-N 1"-OLW-011200311-101CS1P-N
011-PI-0418
011-TW-0373
DS011-TRJR-480023
011-SC-0028 3/4"-CWS-011019006-101CH2S-P
3/4"-CWS-011019008-101CH2S-P
3/4"-LFL-011200308-101CH2F-N
3/4"-RWA-011200312-301CG0W-N
3/4"-CWS-011200002-101CH2S-N 1"-OLW-011200312-101CS1P-N
011-PI-0429
011-TW-0374
DS011-TRJR-480046
22
PROCESS LINE TO AMD
OUTLET LINE
SC
INLET LINE
011-SC-0031
3/4"-AMI-011036020-103CH2S-P
3/4"-AMI-011036021-103CH2S-P
2"-AMD-011200301-101CH2S-P
21
SAMPLE COOLER OUTLET LINE
SERVICE WATER INLET LINE
OVERFLOW LINE
PI
TW
P&ID NUMBER
1"-OLW-011200321-101CS1P-N
011-PI-0405
011-TW-0372
DS011-TRJR-480095
20
3/4"-RWA-011200321-301CG0W-N 3/4"-AMI-011200002-103CH2S-P
19
19
18 17
18
TYPE 23 SPECIAL SAMPLE CONNECTION HIGH TEMPERATURE GAS AND FLASHING LIQUID SAMPLE SERVICE (TEMP < 65ºC)
TYPE 31 SPECIAL SAMPLE CONNECTION HIGH TEMPERATURE LIQUID SAMPLE SERVICE (TEMP > 65ºC)
17
16
16
NOTE 9
3/4"
NOTE 12
3/4"
13
SOURCE OF DIFFER. PRESS. NOTE 4
3/4"
15
MIN
MIN.
NOTE 9 14
HOT LIQUID LINE
MIN.
15
14
NOTE 12
13
NOTE 1
12
12
11
11
10
10
PI
3/4" 9
9
PI
TW
TW
8
RED. CPLG.
NOTE 1
1/2"
NOTE 5
SWAGE NIPPLE
D
1/2"x1/4"
2"x3/4" SWAGE NIPPLE 2"
3
2
2
3/4"
TRJR
NOTE 8
RED. CPLG. NOTE 1
1/2"
VENDOR
NOTE 6
1/2"x1/4"
NOTE 5
SWAGE NIPPLE
SWAGE NIPPLE
NOTE 8
D
VENDOR TRJR 2"x3/4" 2"
PROCESS PIPING CLASS AMD PIPING CLASS
6
3/4"
MIN.
1/2"x1/4"
MIN.
NOTE 6
1/2"x1/4"
4
3/4"
VENDOR TRJR MIN.
RED. CPLG.
RED. CPLG.
250mm MIN.
OVERFLOW
3/4"x1/2" 7
3/4"x1/2"
5
1/2"
3/4"
3"x3/4" 3/4"
3/4"x1/2"
6
3/4"x1/2"
5
MIN.
3"x3/4"
7
3/4"
4"x3/4" 3/4"
4"X3/4"
PROCESS PIPING CLASS CLD PIPING CLASS
4
250mm MIN.
8
3 2
25
AMD
1
1
OLW
SC
AMD OUTLET LINE
SERVICE WATER INLET LINE
3/4"-AMI-011036012-103CS2D-H
2"-AMD-011200302-101CH2S-P
3/4"-RWA-011200314-301CG0W-N
011-SC-0048 3/4"-AMD-011079312-103CH2S-P
2"-AMD-011200303-101CH2S-P
SC
011-SC-0044
INLET LINE
SAMPLE COOLER OUTLET LINE
OVERFLOW LINE
PI
TW
P&ID NUMBER
3/4"-AMI-011200001-103CS2D-N
1"-OLW-011200314-101CS1P-N
011-PI-0402
011-TW-0345
DS011-TRJR-480094
3/4"-RWA-011200316-301CG0W-N 3/4"-AMD-011200001-103CH2S-N
1"-OLW-011200316-101CS1P-N
011-PI-0404
011-TW-0362
DS011-TRJR-480233
INLET LINE
CLD OUTLET LINE
PI
TW
P&ID NUMBER
011-SC-0004 3/4"-CWS-011044010-106CH2S-P
3/4"-CWS-011044011-106CH2S-P
2"-CLD-011200303-101CH2S-N
011-PI-0430
011-TW-0394
DS011-TRJR-480114
011-SC-0007 3/4"-NAP-011021013-103CH2S-N
3/4"-NAP-011021014-103CH2S-N
2"-CLD-011200305-101CH2S-P
011-PI-0431
011-TW-0395
DS011-TRJR-480051
011-SC-0021 3/4"-CWS-011033017-106CH2S-N
3/4"-CWS-011033018-106CH2S-N
2"-CLD-011200308-101CH2S-N
011-PI-0432
011-TW-0396
DS011-TRJR-480088
011-SC-0026 3/4"-PRO-011033020-103CH2S-N
3/4"-PRO-011033021-103CH2S-N
2"-CLD-011200309-101CH2S-N
011-PI-0433
011-TW-0397
DS011-TRJR-480087
011-SC-0029 3/4"-CWS-011021002-101CH2S-N
3/4"-CWS-011021003-101CH2S-N
2"-CLD-011200310-101CH2S-N
011-PI-0434
011-TW-0398
DS011-TRJR-480050
011-SC-0045 1"-CWS-011036005-101CH4S-N
1"-CWS-011036004-101CH2S-N
2"-CLD-011200312-101CH2S-N
011-PI-0436
011-TW-0403
DS011-TRJR-480093
011-SC-0051 3/4"-SLP-011001003-103CS1P-N
3/4"-SLP-011001004-103CS1P-N
2"-CLD-011200329-101CH2S-N
011-PI-0458
011-TW-0469
DS011-TRJR-480001
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- USE BLOCK VALVE WHERE REQUIRED IN JERES-C-102. 2- BEVEL ALL OPEN ENDS OF SIMPLE CONNECTIONS AT 45º ANGLE WITH 75 mm MINIMUM EXTENSION. 3- USE FLUSHING OIL AFTER SAMPLING HEAVY LIQUID. 4- ANY CONVENENTLY LOCATED SOURCE OF DIFFERENTIAL PRESSURE, CONTROL VALVE, HEAT EXCHANGERS,ETC. 5- LOCATE SAMPLE OUTLET ACCESIBLE FROM GRADE OR SERVICE PLATFORM. 6- THREADED FEMALE CONNECTION FOR SAMPLE CYLINDER. 7- FLANGE RATING CL300. 8- USE BLIND FLANGE INSTEAD OF PLUG WHEN DOUBLE VALVES REQUIRED AS PER DRAIN A VENT ARRANGEMENT IN JERES C-103. 9- TAKE SAMPLE CONNECTION FROM LATERAL SIDE. 10- TAKE SAMPLE CONNECTION FROM TOP OH HORIZONTAL LINE. 11- IF REQUIRED. USE REDUCER IF BLOCK VALVES ARE NOT 3/4". 12- 1" MINIMUM SIZE FOR 60 mm CORROSION ALLOWANCE MATERIAL SPECIFICATIONS.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
OUTLET LINE
04
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS/ HCR
JAL
03
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS / MAC
JAL
01
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
00
24-SEP-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
AVS / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32 FLO
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER FLUSHING OIL
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 SAMPLE DETAILS No 3
Project:
011-074
011-078 011-075 011-080 011-077
Item Tags :
ORIGINAL SIGNED IN PROJECT FILE
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480275.pid
Discipline: PRO
SA-JER-DS011-TRJR-480275 2271-011-PID-0021-200
REV:
04
Sheet: 3 of 3
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
37
36
36
35
35
34
34
33
33
NOTE 8
32
32
31
31
NOTE 4
30
30
29
29
28
VENDOR
28
TR
27
27
26
26
25
AXA
AXA
AXA
AI
AXA
FAL
AXA
AXA
AXA
AXA
AI
AXA
0024 D
0024 C
0024 B
0024 B
0024 A
0055
0025 E
0025 D
0025 C
0025 B
0025 B
0025 A
NEW RESULTS ARE READY
24
VALIDATION ACTIVE
STREAM 1 ACTIVE
COMMON ALARM
NEW RESULTS ARE READY
VALIDATION ACTIVE
25
COMMON ALARM
AXA 0100 A
COMMON SHELTER ALARM
24
23
23
22 21
17
1"-IAI-011230301-301CG2P-N
AXS 0100 A
MIN.
6239
27
21
1" CL 150
TP-0001
20 19
22
HVAC#
1"-N2L-011230301-101CS1P-N
TP-0002 NOTE 6
4127
3/4"
18
MIN.
D
AXS
FSL
AXS
0024 A
0055
0025 A
FREEZING POINT
NOTE 1
20 19
95% ASTM D86
18
17
17
011-AS-0001 NOTE 1
16 15
FLASH POINT
95% ASTM D86
CLOUD POINT
AXS 0011 A
14
16
AXS 0012 A
15
AXS 0022 A
14
13
13
HVAC# NOTE 9
12
1" CL150
12
1" CL150 1"-DIE-011230001-101CS1P-N
11
11
10
10
FAULT
NEW RESULTS ARE READY
VALIDATION ACTIVE
AXA 0011 B COMMON ALARM
AI 0011 B
3/4"
AXA 0011 A
4 3
250mm MIN.
5
2"x1"
101CS1P 101CH2S
6
AXA 0012 E STREAM 1 ACTIVE
AXA 0012 D
AXA 0012 C
AXA 0012 B
NEW RESULTS ARE READY
VALIDATION ACTIVE
COMMON ALARM
AI 0012 B
FAULT
AXA 0012 A
AXA 0022 D
AXA 0022 C
AXA 0022 B
NEW RESULTS ARE READY
VALIDATION ACTIVE
AI 0022 B
9
AXA 0022 A
8
COMMON ALARM
7
1"-OLW-011230304-101CS1P-N
STREAM 1 ACTIVE
AXA 0011 C
3/4"-OLW-011230301-101CS1P-N
7
AXA 0011 D
2"-CLD-011230301-101CH2S-N
8
AXA 0011 E
FAULT
MIN.
MIN.
9
6 5 4 3
2
2 25
1
6897
1
OLW
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-AS-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 2, 3, 5 - DELETED. 1- HVAC AIR LOW FLOW COMMON ALARM. 4- TO ATMOSPHERE AT SAFE LOCATION. 6- NITROGEN IS USED AS BACK UP FOR A LOST OF INSTRUMENT AIR. 7- BLIND IS TURN AT OPEN POSITION DUE TO CONTINUOUS DRAINING SAMPLE OF ANALYZER. 8- ANALYZER VENDOR SCOPE OF SUPPLY. 9- SAMPLE RECOVERY UNIT CONNECTIONS. 10- CONNECTION BETWEEN SRY DRAIN HEADER AND SRY TANK IS BY TR WITH LINE NUMBER (1"-DIE-011230002-101CS1P-N).
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MCG / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
Item Tags : 011-AS-0001
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 ANALYZER AUXILIARY DETAILS No 1 ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480289 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480289 2271-011-PID-0021-230
REV: 05
Sheet: 1 of 3
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
NOTE 8 37
37
NOTE 4
36
36 35
VENDOR TR
35 34
34
33
33
32
32
31
31
30
30
29
29
STREAM 1 ACTIVE
28 27
AXA 0026 E
26
NEW RESULTS ARE READY AXA 0026 D
VALIDATION ACTIVE AXA 0026 C
COMMON ALARM AXA 0026 B
95% RECOVERY AI 0026 B
28
AXA 0026 A
27
FAL 0066
26
25
AXA
25
COMMON SHELTER ALARM
0101 A
24
24
23
23
3/4" V 22 21
1" CL150 17
1"-IAI-011230302-301CG2P-N MIN.
6251
27
1"-N2L-011230302-101CS1P-N
1" CL300
FSL 0066
95% ASTM D86
20 19
AXS 0026 A
TP.0001
AXS 0101 A
3/4"
21
NOTE 1
20
ST
TP.0002 MIN.
D
011-AS-0002
18
10 6320
MIN.
MIN.
NOTE 6
6252
22
1"-MPS-011230301-103CS1P-H
1"-MPS-011230302-103CS1P-H 3/4" 1"x3/4"
19
600#
1"x3/4"
1"-MPC-011230301-103CS1P-H
1" CL300
MIN. 3/4"
3/4"
13
NOTE 3
3/4"
18
6319
17 16
17 32
1"-CWS-011230302-101CS1P-N
TP.0003 3/4"
AXS 0013 A
15
16
NC
AXS 0015 A
15
MIN.
14 13
VISCOSITY AT 150ºC
95% ASTM D86
2619
1"x3/4" 3/4" 1"x3/4"
32
14
1"-CWR-011230302-101CS1P-N
NOTE 9 1" CL150
TP.0004
MIN.
2620
3/4"
12
13
1" CL150
12
11
11
FAULT
8
STREAM 1 ACTIVE
AXA 0013 D NEW RESULTS ARE READY
AXA 0013 C
AXA 0013 B
VALIDATION ACTIVE
COMMON ALARM
AI 0013 B
AXA 0013 A
AXA 0015 B
95% RECOVERY
7 6 5
MIN.
101CS1P 101CH2S
6 5 4 3 2 1
250 mm
NOTE 7
8 7
2"-CLD-011230302-101CH2S-P
1
9
3/4"
2"x1"
2
10
AXA 0015 A
COMMON ALARM
4 3
AI 0015 B
3/4"-OLW-011230302-101CS1P-N
9
AXA 0013 E
FAULT
1"-OLW-011230305-101CS1P-N 1"-HFO-011230101-101CS1P-P
10
OLW
25 6893
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-AS-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 2,5 - DELETED. 1- HVAC AIR LOW FLOW COMMON ALARM. 3- CHECK VALVE TO BE LOATED AT HIGHEST POINT AS CLOSE AS POSSIBLE TO CONDENSATE RETURN HEADER. 4- TO ATMOSPHERE AT SAFE LOCATION. 6- NITROGEN IS USED AS BACK UP FOR A LOST OF INSTRUMENT AIR. 7- BLIND IS TURN AT OPEN POSITION DUE TO CONTINUOS DRAINING SAMPLE OF ANALYZER. 8- ANALYZER VENDOR SCOPE OF SUPPLY. 9- SAMPLE RECOVERY UNIT CONNECTIONS. 10- CONNECTION BETWEEN SRY DRAIN HEADER AND SRY TANK IS BY TR WITH LINE NUMBER (1"-HFO-011230002-101CS1P-N).
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MCG / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 011-075 011-080
Item Tags : 011-AS-0002
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 ANALYZER AUXILIARY DETAILS No 2 ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480290.pid
Discipline: PRO
SA-JER-DS011-TRJR-480290 2271-011-PID-0021-230
REV:
05
Sheet: 2 of 3
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
37
36
36
35
35
34
34
33
33
32
32
NOTE 6
31
31
NOTE 4
30
30
29
29
28
28
VENDOR
27
TR
27
26
26
25
25
24
24
23
23
22
22
21
17
1"-IAI-011230303-301CG2P-N
TP.0001
21
MIN.
6271
20
AXA
0102 A
19
20
COMMON PANEL 0102 A ALARM
AXS
19
011-ALP-0001
18
18
NOTE 8
17
17
16
16
15
15
ST
NOTE 9
14
1" CL150 TP.0008
13
14
14 13
1/2"CL150
12
12
1"x1/2" 11
1"-OLW-011230303-101CS1P-N
11 10 9 8 7
10 9 8 7
6
6
5
5
OLW 4
4
3
3
2
2
1
1
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-AS-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 2, 3 - DELETED. 1- NITROGEN IS USED AS BACK UP FOR A LOST OF INSTRUMENT AIR. 4- TO ATMOSPHERE AT SAFE LOCATION. 5- PROVIDE WEEP HOLE =6mm AT LOW POINT. 6- ANALYZER VENDOR SCOPE OF SUPPLY. 7- STEAM TRACING CONDENSATE CONNECTION TO CONDENSATE HEADER. 8- O2 ANALYSER 011-AT-0004 AND SO2 ANALYZER 011-AT-0003 LOCATED IN 011-ALP-0001. 9- STEAM TRAP TYPICAL ARRANGEMENT BY PIPING.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MCG / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
Item Tags :011-ALP-0001
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 ANALYZER AUXILIARY DETAILS No 3 ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480291 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480291 2271-011-PID-0021-230
REV: 05
Sheet: 3 of 3
SCALE: NONE Format:
A1
41
NOTE 1
NOTE 1
NOTE 1
011-US-002
011-US-032
N
NOTE 1
011-US-004
011-US-033
NOTE 1
NOTE 1
011-US-034
NOTE 1
011-US-006
011-US-035
011-US-136
NOTE 1
NOTE 1
011-US-036
011-US-008
MI N.
NOTE 1
011-US-010
011-US-012
011-US-037 1"x3/4"
MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
22
MIN.
MIN.
MIN.
MIN. MIN.
MIN.
NC 2"x1" 2"-LPS-011071346-101CS1P-H
2"x1" MIN.
29
MIN.
28
MIN.
27
LPS PID-4803076932 26
NOTE 2
2"-RWA-011073303-301CG0W-N
NOTE 4
3"-SAI-011074301-301CG2P-N
NOTE 4
4"-N2L-011074302-101CS1P-N
MIN.
RWA PID-480307 6933 24
MIN.
23
MIN.
SAI PID-480307 6934 22 MIN.
MIN.
N2L
20
TO
5
MIN.
SAI
31
25
MIN.
MIN.
MIN.
MIN.
23
MIN.
MIN.
24
33
MIN.
MIN.
MIN.
25
RWA
TE NO
2"-LPS-011071303-101CS1P-H
NOTE 3
34
MIN.
MIN.
MIN.
MIN.
MIN.
LPS
MIN.
MIN.
MIN.
27
ER EF R
45°
MIN.
MIN.
35
30
MIN.
28
36
1"x¾"
MIN.
MIN.
1"-RWA-011073344-301CG0W-N
1"-SAI-011074344-301CG2P-N
1"-N2L-011074328-101CS1P-N
2"x1"
X) MA E ( IN) D A M GR E( TO RAD 0 0 G O 12 0T 60 TE 6 NO
MIN. 29
37
32
NC
MIN.
38
NC 1"-LPS-011071316-101CS1P-H
1"-SAI-011074314-301CG2P-N
1"-RWA-011073314-301CG0W-N
0 15
2"x1"
2"x1"
2"x1"
1"x3/4" NC
0 15 0 15
1"-LPS-011071313-101CS1P-H
7 TE NO
31 30
39
MIN.
L N2
UTILITY STATION (STANDARD LAYOUT)
1"-RWA-011073311-301CG0W-N
I SA
1"-SAI-011074311-301CG2P-N
RW
A
MIN.
MIN.
MIN.
NC 1"-LPS-011071311-101CS1P-H
1"-RWA-011073309-301CG0W-N
1"-SAI-011074309-301CG2P-N
NC 1"-LPS-011071345-101CS1P-H
1"-RWA-011073343-301CG0W-N
1"-SAI-011074343-301CG2P-N
1"-N2L-011074326-101CS1P-N
1"-SAI-011074438-301CG2P-N
1"-RWA-011073439-301CG0W-N
S LP
DETAIL "A" 32
21
NOTE 1
1"x3/4"
1"x3/4"
1"x3/4" NC 1"-LPS-011071442-101CS1P-H
1"-LPS-011071309-101CS1P-H
1"-SAI-011074307-301CG2P-N
1"-RWA-011073307-301CG0W-N
NC
NC 1"-LPS-011071343-101CS1P-H
1"-RWA-011073341-301CG0W-N
1"-SAI-011074341-301CG2P-N
1"-N2L-011074325-101CS1P-N
1"-LPS-011071342-101CS1P-H
1"-RWA-011073340-301CG0W-N
NC
1"x3/4"
1"x3/4"
1"x3/4" 1"-SAI-011074340-301CG2P-N
1"-N2L-011074323-101CS1P-N
1"-LPS-011071308-101CS1P-H
1"-SAI-011074306-301CG2P-N
1"-RWA-011073306-301CG0W-N
2"x1"
2"-LPS-011071341-101CS1P-H
1"-SAI-011074339-301CG2P-N
1"-RWA-011073339-301CG0W-N
NC
NC
1"x3/4"
1"x3/4" NC
1"x3/4"
1"-N2L-011074322-101CS1P-N
33
1"-LPS-011071306-101CS1P-H
34
1"-SAI-011074304-301CG2P-N
35
1"-LPS-011071339-101CS1P-H
36
1"-SAI-011074337-301CG2P-N
1"-N2L-011074320-101CS1P-N
37
1"-RWA-011073337-301CG0W-N
38
1"-RWA-011073304-301CG0W-N
NC
39
26
41
NOTE 1
40
1"x3/4"
40
NOTE 1
MIN.
N2L PID-480307 6935
MIN.
19
MIN.
18
MIN.
17
20 19
MIN.
18
21
17
MIN.
MIN.
16
16
MIN.
MIN. 15
15
MIN. 14
MIN.
MIN.
MIN.
14
MIN. MIN.
MIN.
13
MIN.
13
MIN.
2"x1"
2"x1"
2"x1"
12
2"x1"
10
1"-SAI-011074328-301CG2P-N
1"-RWA-011073328-301CG0W-N
7 6 5 4
1"x3/4"
1"x3/4"
1"x3/4"
NC
NC
1"-LPS-011071330-101CS1P-H
8
SC-0050 DS011-TRJR-480274
3
7793
2 1
9
3/4"-RWA-011200322-301CG0W-N
1"-N2L-011074327-101CS1P-N
1"-SAI-011074313-301CG2P-N
1"-RWA-011073313-301CG0W-N
1"-LPS-011071315-101CS1P-H
1"-SAI-011074329-301CG2P-N
NC 1"x3/4"
1"x3/4"
1"x3/4"
1"-RWA-011073329-301CG0W-N
1"-LPS-011071331-101CS1P-H
1"-SAI-011074334-301CG2P-N
1"-RWA-011073334-301CG0W-N
1"-LPS-011071336-101CS1P-H NC
1"-SAI-011074312-301CG2P-N
1"-RWA-011073312-301CG0W-N
NC
1"-LPS-011071314-101CS1P-H
1"-SAI-011074436-301CG2P-N
1"-RWA-011073437-301CG0W-N
NC 1"x3/4"
1"x3/4"
1"x3/4"
1"-LPS-011071440-101CS1P-H
1"-SAI-011074335-301CG2P-N
1"-RWA-011073335-301CG0W-N
NC
1"-LPS-011071337-101CS1P-H
1"-SAI-011074310-301CG2P-N
1"-RWA-011073310-301CG0W-N
1"-LPS-011071312-101CS1P-H NC
1"-N2L-011074324-101CS1P-N
1"-SAI-011074333-301CG2P-N
1"-RWA-011073333-301CG0W-N
1"-LPS-011071335-101CS1P-H NC
1"x3/4"
1"x3/4"
NC
NC
1"-SAI-011074308-301CG2P-N
1"-RWA-011073308-301CG0W-N
2"x1" 1"-LPS-011071310-101CS1P-H
1"-SAI-011074435-301CG2P-N
1"-RWA-011073436-301CG0W-N
1"-LPS-011071439-101CS1P-H
1"-SAI-011074336-301CG2P-N
1"-RWA-011073336-301CG0W-N
NC
1"-LPS-011071338-101CS1P-H
1"-SAI-011074305-301CG2P-N
1"-RWA-011073305-301CG0W-N
2"x1" 1"-LPS-011071307-101CS1P-H
1"-N2L-011074321-101CS1P-N
1"-SAI-011074338-301CG2P-N
1"-LPS-011071340-101CS1P-H
1"-RWA-011073338-301CG0W-N
NC
1"x3/4"
9392
2"x1"
2"x1"
2"x1"
2"x1"
2"x1"
2"x1" DS011-TRJR-480274
1"x3/4"
3
SC-0039
NC
3/4"-RWA-011200319-301CG0W-N
1"-N2L-011074303-101CS1P-N 1"x3/4"
4
1"-SAI-011074303-301CG2P-N
5
1"-RWA-011073323-301CG0W-N
6
1"-LPS-011071325-101CS1P-H
7
NC
8
MIN.
11
10 9
2"x1"
MIN.
MIN. 11
2"x1"
MIN.
12
2"x1"
MIN.
011-US-001 NOTE 1
011-US-031 NOTE 1
011-US-003 NOTE 1
011-US-030 NOTE 1
011-US-133 NOTE 1
011-US-005
011-US-029
NOTE 1
NOTE 1
011-US-007
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- HOSE CONNECTIONS SHALL BE DESIGN ACCORDING TO JERES-H-001 AND JERES-L-310.
NOTES 1- EACH UTILITY TAKE-OFF CONNECTION SHALL BE LOCATED AT THE TOP OF THE HORZONTAL MAIN HEADER OR AUXILIARY HEADER. 2- RWA MAIN HEADER IS SHOWN ON PID: SA-JER-DS0111-TRJR-480207 AND 480208. 3- LPS HEADER IS SHOWN ON PID: SA-JER-DS011-TRJR-480201 THROUGH 480206. 4- SAI AND N2L MAIN HEADER ARE SHOWN ON PID: SA-JER-DS011-TRJR-480211 AND 480212. 5- THE CONNECTORS AND COLOR CODING FOR HOSE CONNECTION SHALL BE STANDARDIZE AS FOLLOWS: UTILITY
HOSE CONNECTION
COLOR CODE
AIR
3/4 INCH IRON DIXON AIR KING AM-8
GREEN / GRAY STRIP
NITROGEN
1-INCH STEEL WING NUT UNION
GREEN / ORANGE STRIPE
RAW WATER
1-INCH BRASS AEROQUIP S101
BLUE
STEAM
1-INCH STEEL DIXON BOSS WF-36
WHITE
6- ELEVATION NOT HIGHER THAN 1200 mm ABOVE FINISHED PLANT GRADE OR ABOVE PLATFORM OF MULTILEVEL EQUIPMENT BUT NOT LOWER THAN 600 mm. 7- MINIMUM 150 mm CLEARANCE BETWEEN EACH OTHER.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
011-US-028 NOTE 1
NOTE 1
011-US-134 NOTE 1
011-US-009 NOTE 1
011-US-026
011-US-027 NOTE 1
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
011-US-025
011-US-011
NOTE 1
1
NOTE 1
NOTE 1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MSS / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
RDP / MAC
JAL
00
16-FEB-2010
IFD
IFD: ISSUED FOR DESIGN
IRG / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS.
2
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 UTILITY STATIONS No 1 ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480306.pid
Discipline: PRO
SA-JER-DS011-TRJR-480306 2271-011-PID-0021-261
REV:
05
Sheet: 1 of 7
SCALE: NONE Format:
A1
3/4"-RWA-011200326-301CG0W-N
MIN.
011-US-047
MIN. MIN.
MIN.
1"x3/4"
011-US-041
MIN.
MIN.
MIN. 1"-N2L-011074332-101CS1P-N
011-US-019
MIN. MIN.
1"-RWA-011073330-301CG0W-N
1"-RWA-011073331-301CG0W-N
MIN.
1"-SAI-011074330-301CG2P-N
MIN.
MIN.
MIN.
MIN.
MIN.
NOTE 3
2"-LPS-011071303-101CS1P-H
1"-RWA-011073322-301CG0W-N
1"-N2L-011074333-101CS1P-N
NC
1"-LPS-011071333-101CS1P-H
1"-SAI-011074331-301CG2P-N MIN.
1"-LPS-011071352-101CS1P-H NC
1"-RWA-011073350-301CG0W-N
NC
011-US-042
MIN. MIN. 1"-LPS-011071332-101CS1P-H
34
NOTE 1
MIN.
27
LPS 6932 PID-480306
36
2"x1"
NOTE 1
MIN.
011-US-017
37
33 32
NC
MIN.
2"x1" NOTE 1
38
35
MIN.
NOTE 1
39
31
1"-LPS-011071324-101CS1P-H
MIN.
40
2"x1"
MIN.
41
MIN. 2"x1"
NC
NC
NC
2"x1"
1"-SAI-011074354-301CG2P-N
1"-RWA-011073349-301CG0W-N
1"-LPS-011071350-101CS1P-H NC
1"-SAI-011074348-301CG2P-N 1"x3/4"
1"-RWA-011073347-301CG0W-N
1"-SAI-011074347-301CG2P-N 1"x3/4"
MIN.
1"-SAI-011074350-301CG2P-N 1"x3/4"
011-US-046 1"-LPS-011071351-101CS1P-H
011-US-045 1"-SAI-011074349-301CG2P-N 1"x3/4"
011-US-044
1"-RWA-011073348-301CG0W-N
NOTE 1
1"-LPS-011071349-101CS1P-H NC
NOTE 1
MIN.
28
26
NOTE 1
1"x3/4"
MIN.
MIN.
1"-N2L-011074331-101CS1P-N 2"x1"
MIN.
1"-LPS-011071334-101CS1P-H NC
9397
1"-RWA-011073332-301CG0W-N
SC-0040 DS011-TRJR-480274
011-US-043 1"-SAI-011074332-301CG2P-N 1"x3/4"
7824
NOTE 1
NOTE 1
1"-N2L-011074329-101CS1P-N
011-US-048
DS011-TRJR-480275
3/4"-RWA-011200311-301CG0W-N
1"-LPS-011071354-101CS1P-H NC
1"x3/4" 1"-RWA-011073352-301CG0W-N
1"-SAI-011074352-301CG2P-N
1"-N2L-011074330-101CS1P-N
NC
SC-0027
1"-SAI-011074322-301CG2P-N
1"x3/4"
1"x3/4"
2"x1"
1"-RWA-011073354-301CG0W-N
NOTE 1
MIN.
1"-SAI-011074319-301CG2P-N
29
2"x1"
1"-LPS-011071320-101CS1P-H
30
1"-SAI-011074318-301CG2P-N
31
011-US-015
1"-LPS-011071317-101CS1P-H
32
1"-SAI-011074315-301CG2P-N
2"-LPS-011071303-101CS1P-H
33
2"-RWA-011073301-301CG0W-N
34
3"-SAI-011074301-301CG2P-N
4"-N2L-011074302-101CS1P-N
35
1"-LPS-011071356-101CS1P-H
NOTE 1
011-US-014
1"x3/4"
NOTE 1
37
1"-LPS-011071321-101CS1P-H NC
RWA
1"-LPS-011071353-101CS1P-H
N2L
1"-RWA-011073319-301CG0W-N
TO HEADER
1"-RWA-011073351-301CG0W-N
TO HEADER
NC
6937 DS011-TRJR-480314
36
011-US-049
1"x3/4"
6939 DS011-TRJR-480314
38
011-US-050
LPS
1"-RWA-011073318-301CG0W-N
N
SAI
1"-RWA-011073315-301CG0W-N
39
TO HEADER
NOTE 1
1"x3/4"
TO HEADER
40
NOTE 1
1"x3/4"
6936 DS011-TRJR-480314
1"-SAI-011074351-301CG2P-N
6938 DS011-TRJR-480314
41
30 29 28 27
MIN.
LPS
26
MIN.
MIN.
25
MIN.
RWA 6933PID-480306
MIN.
MIN.
MIN.
MIN.
NOTE 2 2"-RWA-011073303-301CG0W-N
MIN.
24
25
MIN.
RWA
24
MIN.
23
MIN.
MIN.
SAI 6934 PID-480306
MIN.
MIN.
NOTE 4
MIN.
3"-SAI-011074301-301CG2P-N
MIN.
22
23
MIN.
SAI 22
MIN.
21
21
MIN.
MIN.
MIN. MIN.
19
MIN.
MIN.
N2L 20
MIN.
19
MIN.
MIN.
18
MIN.
4"-N2L-011074302-101CS1P-N
MIN.
NOTE 4
N2L 6935 PID-480306 20
18
MIN.
MIN.
MIN.
17
17
MIN.
16
2"x1"
15
16
MIN.
MIN.
15 MI N.
MIN.
14
2"x1"
2"x1"
2"x1"
14
S LP
RW
A
MIN.
MIN.
MIN.
MIN.
12
1"-N2L-011074334-101CS1P-N
1"-SAI-011074321-301CG2P-N
1"-N2L-011074306-101CS1P-N
1"-SAI-011074320-301CG2P-N
1"-RWA-011073320-301CG0W-N
1"-LPS-011071322-101CS1P-H
1"-RWA-011073321-301CG0W-N
1"-LPS-011071323-101CS1P-H
2"x1" 1"-N2L-011074307-101CS1P-N
1"-SAI-011074324-301CG2P-N
1"-RWA-011073324-301CG0W-N
1"-LPS-011071326-101CS1P-H
1"-N2L-011074308-101CS1P-N
1"-SAI-011074325-301CG2P-N
1"-RWA-011073325-301CG0W-N
1"-LPS-011071327-101CS1P-H
1"-SAI-011074317-301CG2P-N
1"-RWA-011073317-301CG0W-N
1"-LPS-011071319-101CS1P-H
3/4"-RWA-011200301-301CG0W-N
1"-SAI-011074356-301CG2P-N
1"-RWA-011073356-301CG0W-N
1"-LPS-011071358-101CS1P-H
1"-LPS-011071357-101CS1P-H
1"-SAI-011074353-301CG2P-N
1"-RWA-011073353-301CG0W-N
1"-LPS-011071355-101CS1P-H
1"-SAI-011074326-301CG2P-N
1"-RWA-011073326-301CG0W-N
1"-LPS-011071328-101CS1P-H
MIN.
1"-SAI-011074327-301CG2P-N
1"-RWA-011073327-301CG0W-N
1"-LPS-011071329-101CS1P-H
1"-N2L-011074372-101CS1P-N
6
1"-SAI-011074316-301CG2P-N
7
1"-RWA-011073316-301CG0W-N
8
1"-LPS-011071318-101CS1P-H
9
1"-SAI-011074355-301CG2P-N
MIN. 10
1"-RWA-011073355-301CG0W-N
2"x1"
11
2"x1"
2"x1"
12
2"x1"
13
2"x1"
13
I SA
11 10
L N2
9 8 7 TE NO
7
0 15
UTILITY STATION (STANDARD LAYOUT) 0 15
DETAIL "A"
6
0 15
NOTE 1
NOTE 1
011-US-024 NOTE 1
011-US-051 NOTE 1
011-US-052
011-US-016
011-US-022
011-US-021
NOTE 1
NOTE 1
NOTE 1
NOTE 1
NOTE 1
SC-0022
SC-0024
011-SC-0008
DS011-TRJR-480274
DS011-TRJR-480274
DS011-TRJR-480274
7820
7821
9386
NC
NC
NC
011-US-018
011-US-020
NOTE 1
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- HOSE CONNECTIONS SHALL BE DESIGN ACCORDING TO JERES-H-001 AND JERES-L-310.
NOTES 1- EACH UTILITY TAKE-OFF CONNECTION SHALL BE LOCATED AT THE TOP OF THE MAIN HEADER OR AUXILIARY HEADER. 2- RWA MAIN HEADER IS SHOWN ON PID: SA-JER-DS0111-TRJR-480209. 3- LPS MAIN HEADER IS SHOWN ON PID: SA-JER-DS111-TRJR-480201 AND 480206. 4- N2L AND SAI MAIN HEADER ARE SHOWN ON PID: SA-JER-DS111-TRJR-480211. 5- THE CONNECTORS AND COLOR CODING FOR HOSE CONNECTION SHALL BE STANDARDIZE AS FOLLOWS: UTILITY
HOSE CONNECTION
COLOR CODE
AIR
3/4 INCH IRON DIXON AIR KING AM-8
GREEN / GRAY STRIP
NITROGEN
1-INCH STEEL WING NUT UNION
GREEN / ORANGE STRIPE
RAW WATER
1-INCH BRASS AEROQUIP S101
BLUE
STEAM
1-INCH STEEL DIXON BOSS WF-36
WHITE
6- ELEVATION NOT HIGHER THAN 1200 mm ABOVE FINISHED PLANT GRADE OR ABOVE PLATFORM OF MULTILEVEL EQUIPMENT BUT NOT LOWER THAN 600 mm. 7- MINIMUM 150 mm CLEARANCE BETWEEN EACH OTHER. This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
4 1"x¾"
45°
ER EF R
TO
TE NO
3
5
2
NOTE 1
1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MSS / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
RDP / MAC
JAL
00
16-FEB-2010
IFD
IFD: ISSUED FOR DESIGN
MMG / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
APPR/AUTH BY
REV
GENERAL NOTES
X) MA E ( IN) D A M GR E( TO RAD 0 0 G O 12 0T 60 TE 6 NO
1"x3/4"
1"x3/4"
1"x3/4"
NC 1"x3/4"
1"x3/4"
1"x3/4"
1"x3/4"
011-US-053
NC
NC
NC
NC 1"x3/4"
1"x3/4"
NC
NC 1"x3/4"
011-US-023
3/4"-RWA-011200310-301CG0W-N
1
011-US-013
3/4"-RWA-011200308-301CG0W-N
2
1"x3/4"
3
NC
4
5
NC
5
COMPANY STATUS
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 UTILITY STATIONS No 2
Project:
011-074
011-078 011-075 011-080
Item Tags :
ORIGINAL SIGNED IN PROJECT FILE
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480307 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480307 2271-011-PID-0021-261
REV: 05
Sheet: 2 of 7
SCALE: NONE Format:
A1
41
41
40
NOTE 1
NOTE 1
011-US-064
011-US-061
MI N.
NOTE 1
40
011-US-062
N
1"x3/4"
36
RW
1"-LPS-011071368-101CS1P-H
1"-RWA-011073366-301CG0W-N
1"-SAI-011074365-301CG2P-N
1"-N2L-011074336-101CS1P-N
1"-LPS-011071367-101CS1P-H
32
1"-RWA-011073365-301CG0W-N
33
1"-SAI-011074364-301CG2P-N
34
1"-LPS-011071370-101CS1P-H
1"-SAI-011074367-301CG2P-N
1"-N2L-011074335-101CS1P-N
35
1"-RWA-011073368-301CG0W-N
S LP
A
I SA
37
MIN.
MIN.
MIN.
MIN.
NC
37
39 38
NC
NC
38
1"x3/4"
1"x3/4"
39
36 L N2
35 34 7 TE NO
33
0 15
UTILITY STATION (STANDARD LAYOUT) 0 15
DETAIL "A"
32
0 15
31
31 NC
30 29 28
MIN.
2"-LPS-011071303-101CS1P-H
MIN.
MIN.
LPS 26 6940 PID-480309
NOTE 2
NOTE 4
LPS PID-480314 11724 26
2"-RWA-011073301-301CG0W-N
RWA PID-480314 11725 24
3"-SAI-011074301-301CG2P-N
SAI PID-480314 11726 22
4"-N2L-011074302-101CS1P-N
N2L PID-480314 11727
16
MIN.
15
MIN.
NOTE 1
14 13 12
MIN. 1"-LPS-011071381-101CS1P-H
NC
MIN. MIN. MIN.
7
3/4"-RWA-011200312-301CG0W-N
1"-RWA-011073379-301CG0W-N
NOTE 1
MIN.
NOTE 1
011-US-075
MIN.
1"x3/4"
1"-SAI-011074378-301CG2P-N
011-US-060
MIN.
MIN.
MIN.
1"-LPS-011071378-101CS1P-H
MIN.
1"-N2L-011074342-101CS1P-N MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
2"x1"
3/4"-RWA-011200324-301CG0W-N
1"-LPS-011071380-101CS1P-H NC
17
1"-SAI-011074074-301CG2P-N
1"-RWA-011073378-301CG0W-N
MIN.
1"-RWA-011073375-301CG0W-N
MIN.
18
1"-LPS-011071377-101CS1P-H
1"x3/4"
1"-SAI-011074377-301CG2P-N
20
MIN.
1"-SAI-011074375-301CG2P-N
MIN.
21
19
1"-RWA-011073376-301CG0W-N
1"-N2L-011074345-101CS1P-N
MIN.
2"-RWA-011073381-301CG0W-N
MIN.
2"-LPS-011071383-101CS1P-H
1"-LPS-011071379-101CS1P-H NC
1"-N2L-011074341-101CS1P-N
MIN.
1"-SAI-011074363-301CG2P-N
MIN.
23
1"x3/4"
1"-RWA-011073377-301CG0W-N
1"-RWA-011073364-301CG0W-N
1"x3/4"
1"-SAI-011074376-301CG2P-N
1"-LPS-011071366-101CS1P-H
1"-N2L-011074350-101CS1P-N
1"-SAI-011074387-301CG2P-N
1"-LPS-011071390-101CS1P-H
1"-RWA-011073388-301CG0W-N
NC
MIN. MIN.
NC
1"-SAI-011074442-301CG2P-N
NOTE 1
1"x3/4"
1"x3/4" 1"-SAI-011074388-301CG2P-N
1"-RWA-011073389-301CG0W-N
1"-LPS-011071391-101CS1P-H
1"-N2L-011074349-101CS1P-N
1"-SAI-011074385-301CG2P-N
2"-SAI-011074386-301CG2P-N
1"x3/4"
MIN.
9 8
1"-RWA-011073386-301CG0W-N
NC 1"-LPS-011071388-101CS1P-H
2"x1"
2"x1" 2"-RWA-011073387-301CG0W-N
2"-LPS-011071389-101CS1P-H
10
NC
1"x3/4"
1"x3/4" 2"x1" NC
15
11
1"-RWA-011073443-301CG0W-N
MIN.
18
12
2"-LPS-011071303-101CS1P-H
2"-N2L-011074344-101CS1P-N 2"-SAI-011074380-301CG2P-N
MIN.
NOTE 1
MIN.
011-US-084
011-US-140
011-US-085
011-US-082
1"-LPS-011071446-101CS1P-H NC
NOTE 1
NOTE 1
011-US-073
NOTE 1
011-US-074
NOTE 1
NOTE 4
MIN.
MIN.
4"-N2L-011074302-101CS1P-N
19
13
27
MIN.
011-US-083
14
MIN.
3"-SAI-011074301-301CG2P-N
MIN.
MIN.
SAI 6942 PID-480309 22
16
28
MIN.
23
N2L 6943 PID-480309
TO
29
5
25
MIN.
2"-RWA-011073301-301CG0W-N
MIN.
MIN.
RWA 6941 PID-480309 24
17
ER EF R
TE NO
MIN.
25
20
1"x¾"
45 °
27
21
30
X) MA E ( IN) D A M GR E( TO RAD 0 0 G O 12 0T 60 TE 6 NO
11 10 9 8 7
MIN. 1"-LPS-011071382-101CS1P-H
NC
5
NC
MIN. 3
1"-RWA-011073380-301CG0W-N
MIN. MIN.
MIN.
4
MIN.
MIN.
4
MIN.
011-US-080 NOTE 1
011-US-078
1"-N2L-011074346-101CS1P-N
011-US-071
NOTE 1
NOTE 1
1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- HOSE CONNECTIONS SHALL BE DESIGN ACCORDING TO JERES-H-001 AND JERES-L-310.
NOTES 1- EACH UTILITY TAKE-OFF CONNECTION SHALL BE LOCATED AT THE TOP OF THE HORIZONTAL MAIN HEADER OR AUXILIARY HEADER. 2- SWA MAIN HEADER IS SHOWN ON PID: SA-JER-DS011-TRJR-480209. 3- LPS HEADER IS SHOWN ON PID: SA-JER-DS011-TRJR-480201 THROUGH-480206. 4- SAI AND N2L MAIN HEADER ARE SHOWN ON PID: SA-JER-DS011-TRJR-480211. 5- THE CONNECTORS AND COLOR CODING FOR HOSE CONNECTION SHALL BE STANDARDIZE AS FOLLOWS: UTILITY
HOSE CONNECTION
COLOR CODE
AIR
3/4 INCH IRON DIXON AIR KING AM-8
GREEN / GRAY STRIP
NITROGEN
1-INCH STEEL WING NUT UNION
GREEN / ORANGE STRIPE
RAW WATER
1-INCH BRASS AEROQUIP S101
BLUE
STEAM
1-INCH STEEL DIXON BOSS WF-36
WHITE
6- ELEVATION NOT HIGHER THAN 1200 mm ABOVE FINISHED PLANT GRADE OR ABOVE PLATFORM OF MULTILEVEL EQUIPMENT BUT NOT LOWER THAN 600 mm. 7- MINIMUM 150 mm CLEARANCE BETWEEN EACH OTHER.
05
13-MAR-2013
AB
SC-0028
DS011-TRJR-480275
DS011-TRJR-480275
7825
7826
2
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VKB / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JCP / STG
RDP / MAC
JAL
00
16-FEB-2010
IFD
IFD: ISSUED FOR DESIGN
VSC / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
REV
NOTE 1
NOTE 1
GENERAL NOTES
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
2"x1"
2"x1" 1"x3/4"
2"x1" NC 2"x1"
1"-SAI-011074371-301CG2P-N
1"-RWA-011073372-301CG0W-N
1"x3/4"
011-US-077
011-US-079
NOTE 1
011-US-072
3
SC-0006
1
NC
2"-N2L-011074347-101CS1P-N
2"-SAI-011074381-301CG2P-N 2"x1"
2"x1" 1"x3/4"
2"-RWA-011073382-301CG0W-N 2"x1"
1"x3/4"
1"x3/4" NOTE 1
2"-LPS-011071384-101CS1P-H NC 2"x1"
1"-N2L-011074348-101CS1P-N
1"-SAI-011074382-301CG2P-N
1"-RWA-011073383-301CG0W-N
1"-LPS-011071385-101CS1P-H NC
1"-SAI-011074383-301CG2P-N
1"-RWA-011073384-301CG0W-N
NC 1"-LPS-011071386-101CS1P-H
011-US-081
MIN.
1"-LPS-011071374-101CS1P-H
MIN.
2 1
MIN.
7849
6
1"x3/4"
DS011-TRJR-480273
5
1"x3/4"
1"-SAI-011074379-301CG2P-N
NC
MIN.
MIN.
011-SC-0043
1"x3/4"
3/4"-RWA-011200313-301CG0W-N
NOTE 1
MIN.
6
011-US-076
1"-N2L-011074343-101CS1P-N
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-073 011-075 011-072
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-078 Item Tags :
011-075 011-080
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 UTILITY STATIONS No 3 ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480308.pid
Discipline: PRO
SA-JER-DS011-TRJR-480308 2271-011-PID-0021-261
REV:
05
Sheet: 3 of 7
SCALE: NONE Format:
A1
41
1"x3/4"
1"x3/4"
1"x3/4"
2"x1"
NC
MIN.
1"-RWA-011073420-301CG0W-N 2"x1"
1"-LPS-011071423-101CS1P-H NC
1"-LPS-011071371-101CS1P-H
1"-SAI-011074368-301CG2P-N
1"-N2L-011074356-101CS1P-N
NOTE 1
MIN.
2"x1"
011-US-124
MIN. MIN.
1"-SAI-011074419-301CG2P-N
A
I SA
36
L N2
35 34 7 TE NO
31 NC ) AX (M ) E N AD MI GR DE ( O A T R 00 G O 12 0T 60 TE 6 NO
MIN.
1"-LPS-011071418-101CS1P-H
26
MIN.
MIN.
1"-SAI-011074414-301CG2P-N
25
1"-N2L-011074351-101CS1P-N NOTE 3
MIN.
MIN.
MIN. MIN.
NOTE 1
011-US-103 NOTE 1
011-US-102 NOTE 1
011-US-101 NOTE 1
011-US-100 NOTE 1
NOTE 1
011-US-098 NOTE 1
MIN. MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
NC
1"x3/4"
11
2"x1"
2"x1"
MIN.
MIN.
2"x1"
011-US-094
NOTE 1
NOTE 1
NOTE 1
NOTE 1
10
NOTE 1
011-US-087 NOTE 1
NOTE 1
8
NOTE 1
1"-SAI-011074389-301CG2P-N
1"-RWA-011073390-301CG0W-N
7 6 5 4 3
1"x3/4"
NC 1"-LPS-011071392-101CS1P-H 2"x1"
011-US-063
1"x3/4"
011-US-088
011-US-089
1"-SAI-011074390-301CG2P-N
1"-RWA-011073391-301CG0W-N
1"-LPS-011071393-101CS1P-H NC
1"x3/4"
1"x3/4"
011-US-090
1"-SAI-011074391-301CG2P-N
1"-RWA-011073392-301CG0W-N
NC
1"-LPS-011071394-101CS1P-H
1"-N2L-011074360-101CS1P-N
1"-SAI-011074392-301CG2P-N
1"-RWA-011073393-301CG0W-N
1"x3/4"
011-US-091
011-US-092
1"-LPS-011071395-101CS1P-H NC
1"-SAI-011074393-301CG2P-N
1"-RWA-011073394-301CG0W-N
1"-LPS-011071396-101CS1P-H
1"x3/4"
1"x3/4"
NC
NC
1"-N2L-011074361-101CS1P-N
1"-SAI-011074384-301CG2P-N
1"-RWA-011073385-301CG0W-N
1"-LPS-011071387-101CS1P-H
1"-SAI-011074395-301CG2P-N
1"-RWA-011073396-301CG0W-N
NC
011-US-093
NOTE 1
1"-LPS-011071398-101CS1P-H
1"-N2L-011074309-101CS1P-N
1"-SAI-011074394-301CG2P-N
1"-RWA-011073395-301CG0W-N
1"x3/4"
1"x3/4"
1"x3/4"
NC
1"-LPS-011071397-101CS1P-H
1"-SAI-011074396-301CG2P-N
1"-RWA-011073397-301CG0W-N
1"-LPS-011071399-101CS1P-H NC
1"-SAI-011074397-301CG2P-N
1"-RWA-011073398-301CG0W-N
1"-N2L-011074313-101CS1P-N
1"-SAI-011074398-301CG2P-N
1"x3/4"
1"x3/4"
1"x3/4"
1"x3/4"
011-US-099
14
2
011-US-086
1
NOTE 1
NC
NC
NC
NC
1"x3/4"
1"x3/4"
NC
NC 1"x3/4"
1"x3/4"
NC
NC 1"x3/4"
1"x3/4" NOTE 1
011-US-104
MIN.
MIN. NOTE 1
011-US-105
NC 1"-LPS-011071400-101CS1P-H
2"x1"
2"x1"
2"x1" 1"-RWA-011073399-301CG0W-N
2"x1" 1"-LPS-011071401-101CS1P-H
3/4"-RWA-011200321-301CG0W-N
1"-N2L-011074358-101CS1P-N
1"-SAI-011074399-301CG2P-N
1"-RWA-011073400-301CG0W-N
1"-LPS-011071402-101CS1P-H
1"-SAI-011074400-301CG2P-N
1"-RWA-011073401-301CG0W-N
1"-LPS-011071403-101CS1P-H
1"-SAI-011074402-301CG2P-N
1"-RWA-011073403-301CG0W-N
1"-LPS-011071405-101CS1P-H
1"-SAI-011074401-301CG2P-N
1"-RWA-011073402-301CG0W-N
1"-LPS-011071404-101CS1P-H
1"-N2L-011074359-101CS1P-N
1"-SAI-011074403-301CG2P-N
1"-RWA-011073404-301CG0W-N
1"-LPS-011071406-101CS1P-H
1"-SAI-011074405-301CG2P-N
1"-RWA-011073406-301CG0W-N
1"-LPS-011071408-101CS1P-H
1"-SAI-011074406-301CG2P-N
1"-RWA-011073407-301CG0W-N
1"-LPS-011071409-101CS1P-H
1"-SAI-011074407-301CG2P-N
1"-RWA-011073408-301CG0W-N
1"-LPS-011071410-101CS1P-H NC
NC 1"x3/4"
NC
011-US-106
011-US-095 NOTE 1
2"x1"
2"-N2L-011074363-101CS1P-N
1"-SAI-011074404-301CG2P-N
1"-RWA-011073405-301CG0W-N
1"-LPS-011071407-101CS1P-H
1"-SAI-011074409-301CG2P-N
1
1"-RWA-011073410-301CG0W-N
2
1"-LPS-011071412-101CS1P-H
3
MIN.
MIN. 2"x1"
MIN.
MIN. 2"x1"
6
4
15
9
7
5
16
12
2"x1"
2"x1"
MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
MIN. 2"x1"
2"x1"
9
17
13
12 11
N2L 18 PID-4803086943
MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
13
MIN.
NOTE 1
1"-SAI-011074366-301CG2P-N MIN.
1"-LPS-011071369-101CS1P-H
MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
1"x3/4"
011-US-066
14
1"-RWA-011073367-301CG0W-N
MIN.
NC MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
MIN.
15
MIN.
MIN.
16
SAI 20 PID-4803086942 19
1"-SAI-011074369-301CG2P-N
17
8
RWA 22 6941 PID-480308
MIN. NOTE 4
4"-N2L-011074302-101CS1P-N
1"-RWA-011073370-301CG0W-N
MIN.
MIN.
19
10
23
21
MIN.
NOTE 4
3"-SAI-011074301-301CG2P-N
24 LPS 6940 PID-480308
MIN.
MIN. MIN.
NOTE 2
1"-LPS-011071372-101CS1P-H
N2L PID-480310
28 27
1"-N2L-011074362-101CS1P-N
1"x3/4"
2"-RWA-011073301-301CG0W-N
SAI 6946 PID-480310
TO
29
5
1"-RWA-011073415-301CG0W-N
2"-LPS-011071303-101CS1P-H
RWA PID-480310
ER EF R
TE NO
MIN.
21
6947
1"x¾"
MIN.
6945
30
45°
23 22
32
0 15
MIN.
LPS 6944 PID-480310
0 15
DETAIL "A"
MIN. MIN.
33
0 15
UTILITY STATION (STANDARD LAYOUT)
MIN.
25
011-US-121
NOTE 1
26
18
1"x3/4"
RW
37
MIN.
NC
27
20
S LP
2"x1"
28
24
1"-N2L-011074354-101CS1P-N
2"x1"
MIN.
MIN.
29
MIN.
MIN.
2"x1"
2"x1"
1"-RWA-011073369-301CG0W-N
NC
NC 1"-LPS-011071422-101CS1P-H
1"-RWA-011073421-301CG0W-N
MIN. 30
1"-LPS-011071424-101CS1P-H
1"-SAI-011074420-301CG2P-N
1"-RWA-011073419-301CG0W-N
1"-SAI-011074418-301CG2P-N
1"-N2L-011074353-101CS1P-N
1"-LPS-011071365-101CS1P-H
31
1"-RWA-011073363-301CG0W-N
NC
1"-N2L-011074355-101CS1P-N
38 MIN.
011-US-065 MIN.
011-US-123
MIN.
011-US-122
MIN.
011-US-067
1"x3/4"
NOTE 1
39
NOTE 1
NOTE 1
1"x3/4"
NC 1"-LPS-011071421-101CS1P-H
1"-RWA-011073418-301CG0W-N
2"x1"
2"x1"
2"x1"
1"-SAI-011074417-301CG2P-N
1"-LPS-011071417-101CS1P-H
1"-RWA-011073414-301CG0W-N
1"-LPS-011071420-101CS1P-H
1"-RWA-011073417-301CG0W-N
32
1"-SAI-011074416-301CG2P-N
33
NC
NC
34
1"-LPS-011071419-101CS1P-H
35
1"-RWA-011073416-301CG0W-N
1"-SAI-011074433-301CG2P-N
36
1"-SAI-011074413-301CG2P-N
1"x3/4"
1"x3/4"
37
NOTE 1
1"-SAI-011074362-301CG2P-N
011-US-126
NC
N
41 MI N.
1"-N2L-011074352-101CS1P-N
NOTE 1
011-US-127
38
011-US-125
40
NOTE 1
39
NOTE 1
011-US-128 1"x3/4"
40
NOTE 1
011-US-096
011-US-097
NOTE 1
NOTE 1
011-SC-0031 DS011-TRJR-480275
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRCTION
MV / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRCTION
NPS / STG
RDP / MAC
JAL
00
16-FEB-2010
IFD
IFD: ISSUED FOR DESIGN
MVF / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
APPR/AUTH BY
7874
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- HOSE CONNECTIONS SHALL BE DESIGN ACCORDING TO JERES-H-001 AND JERES-L-310.
NOTES 1- EACH UTILITY TAKE-OFF CONNECTION SHALL BE LOCATED AT THE TOP UP OF THE HORIZONTAL MAIN HEADER OR AUXLUARY HEADER. 2- RWA MAIN HEADER IS SHOWN ON PID: SA-JER-DS0111-TRJR-480209. 3- LPS HEADERS ARE SHOWN ON PID: SA-JER-DS111-TRJR-480201 THROUGH 480206. 4- SAI AND N2L MAIN HEADER ARE SHOWN ON PID: SA-JER-DS111-TRJR-480211. 5- THE CONNECTORS AND COLOR CODING FOR HOSE CONNECTION SHALL BE STANDARDIZE AS FOLLOWS: UTILITY
HOSE CONNECTION
COLOR CODE
AIR
3/4 INCH IRON DIXON AIR KING AM-8
GREEN / GRAY STRIP
NITROGEN
1-INCH STEEL WING NUT UNION
GREEN / ORANGE STRIPE
RAW WATER
1-INCH BRASS AEROQUIP S101
BLUE
STEAM
1-INCH STEEL DIXON BOSS WF-36
WHITE
6- ELEVATION NOT HIGHER THAN 1200 mm ABOVE FINISHED PLANT GRADE OR ABOVE PLATFORM OF MULTILEVEL EQUIPMENT BUT NOT LOWER THAN 600 mm. 7- MINIMUM 150 mm CLEARANCE BETWEEN EACH OTHER. This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-078 011-075 011-080
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 UTILITY STATIONS No 4
Item Tags :
ORIGINAL SIGNED IN PROJECT FILE
Syst./ S-Syst.:
Discipline: PRO
COMPANY Document N° Contractor/Vendor Document N°
SA-JER-DS011-TRJR-480309 2271-011-PID-0021-261
Electronic Filename SA-JER-DS011-TRJR-480309 .pid REV: 05
Sheet: 4 of 7
SCALE: NONE Format:
A1
41
41 MI N.
40
40
N
39
39 38
011-US-069
S LP
RW
A
I SA
37 36
L N2
1"x3/4"
36
MIN.
MIN.
MIN.
NOTE 1 37
MIN.
38
35
NC
35
32 31 30
34 7 TE NO
1"-LPS-011071375-101CS1P-H
33
1"-RWA-011073373-301CG0W-N
1"-SAI-011074372-301CG2P-N
34
0 15
DETAIL "A"
32
0 15
31 NC ) AX (M ) E N AD MI GR DE ( O A T R 00 G O 12 0T 60 TE 6 NO
29 28
30 1"x¾"
ER EF R
45°
MIN. MIN.
23 22 21
2"-RWA-011073301-301CG0W-N
RWA PID-4803096945 24
NOTE 4
3"-SAI-011074301-301CG2P-N
NC
4"-N2L-011074302-101CS1P-N
N2L PID-4803096947
22 21 20
011-SC-0046
3/4"-RWA-011200315-301CG0W-N
16
DS011-TRJR-480274
1"-RWA-011073434-301CG0W-N
7876
15
MIN.
1"x3/4"
23
17
MIN. MIN.
SAI PID-4803096946
18
1"-SAI-011074432-301CG2P-N 14
MIN. 1"-LPS-011071429-101CS1P-H
13
MIN. 1"-RWA-011073426-301CG0W-N
12
MIN. 1"-SAI-011074424-301CG2P-N
11
MIN. 1"-N2L-011074365-101CS1P-N
10
MIN.
1"x3/4"
1"-SAI-011074422-301CG2P-N MIN. 1"-RWA-011073424-301CG0W-N MIN. 1"-LPS-011071427-101CS1P-H 7
MIN. 1"-N2L-011074368-101CS1P-N
DS011-TRJR-480315 11765
DS011-TRJR-480315 11766
DS011-TRJR-480315 11767
8
5 4 3 2 1
LPS
SAI
DS011-TRJR-480315 11759
DS011-TRJR-480315 11761
1"x3/4"
NC
1"-SAI-011074425-301CG2P-N
1"-LPS-011071430-101CS1P-H MIN.
1"-LPS-011071432-101CS1P-H
1"-RWA-011073427-301CG0W-N
4
2"-N2L-011074302-101CS1P-N
6
MIN.
1"-RWA-011073429-301CG0W-N
3"-SAI-011074301-301CG2P-N
DS011-TRJR-480315 11764
MIN.
5
2"-RWA-011073301-301CG0W-N
LPS
7
1"-SAI-011074427-301CG2P-N
2"-LPS-011071303-101CS1P-H
RWA
NC
6
3
SAI
1"-N2L-011074366-101CS1P-N
8
9
N2L
MIN.
1"x3/4"
NOTE 1
NOTE 1
MIN. 1"-LPS-011071437-101CS1P-H
9
1
NOTE 2
19
011-US-112
NOTE 1
NC
10
2
LPS PID-4803096944 26
NOTE 1
1"-LPS-011071373-101CS1P-H
011-US-130
11
NOTE 1
011-US-068
MIN.
NC
011-US-070
1"-SAI-011074370-301CG2P-N 1"-RWA-011073371-301CG0W-N
13 12
1"x3/4"
MIN.
1"x3/4"
15 14
MIN.
011-US-115
16
1"-SAI-011074373-301CG2P-N
17
1"-RWA-011073374-301CG0W-N
18
2"-LPS-011071303-101CS1P-H
NOTE 4 NC 1"-LPS-011071376-101CS1P-H
19
28
NOTE 3
MIN.
24
29
5
25
MIN.
25
20
TO
MIN.
26
TE NO
27
MIN.
27
33
0 15
UTILITY STATION (STANDARD LAYOUT)
RWA
N2L
011-US-118
DS011-TRJR-480315 11760
DS011-TRJR-480315 11763
NOTE 1
NOTES 1- EACH UTILITY TAKE-OFF CONNECTION SHALL BE LOCATED AT THE TOP OF THE HORIZONTAL MAIN HEADER OR AUXILIARY HEADER. 2- RWA MAIN HEADER IS SHOWN ON PID: SA-JER-DS0111-TRJR-480207 AND 480208. 3- LPS MAIN HEADER IS SHOWN ON PID: SA-JER-DS111-TRJR-480201 AND 480204. 4- N2L AND SAI MAIN HEADER ARE SHOWN ON PID: SA-JER-DS111-TRJR-480209 AND 480210. 5- THE CONNECTORS AND COLOR CODING FOR HOSE CONNECTION SHALL BE STANDARDIZE AS FOLLOWS: UTILITY
HOSE CONNECTION
COLOR CODE
AIR
3/4 INCH IRON DIXON AIR KING AM-8
GREEN / GRAY STRIP
NITROGEN
1-INCH STEEL WING NUT UNION
GREEN / ORANGE STRIPE
RAW WATER
1-INCH BRASS AEROQUIP S101
BLUE
STEAM
1-INCH STEEL DIXON BOSS WF-36
WHITE
6- ELEVATION NOT HIGHER THAN 1200 mm ABOVE FINISHED PLANT GRADE OR ABOVE PLATFORM OF MULTILEVEL EQUIPMENT BUT NOT LOWER THAN 600 mm. 7- MINIMUM 150 mm CLEARANCE BETWEEN EACH OTHER. This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
13-MAR-2013
AB
AB: AS BUILT
MJR /STG
AVS/HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR /STG
AVS/MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC /STG
AVS/MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MV/STG
AVS/MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
NPS / STG
RDP / MAC
JAL
00
16-FEB-2010
IFD
IFD: ISSUED FOR DESIGN
JGT / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- HOSE CONNECTIONS SHALL BE DESIGN ACCORDING TO JERES-H-001 AND JERES-L-310.
05
POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074
011-076 Item Tags :
011-075 011-080
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 UTILITY STATIONS No 5 ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480310.pid
Discipline: PRO
SA-JER-DS011-TRJR-480310 2271-011-PID-0021-261
REV:
05
Sheet: 5 of 7
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
37
36
36
35
35
34
34
33
33
32
32
PASS 1 31
31
8"x6" 30
30
16"x8" 29
29
PASS 2
28
28
27
TY
PASS 3
27
OP
OP TY 0097 E
0097 A
26 25
FC 0014 A
24
FY 0014 A
26
FC
FY
0014 B
0014 B
25 24
PASS 4
23
23
22
22
PASS 5
21
21
20
20
19
19
PASS 6
18
18
17
17
PASS 7
16
16
15
15
14
14
PASS 8
9
8 7 6 5
6"-CRU-011015018-106CL2P-H
9
6"-CRU-011015019-106CL2P-H
10
6"-CRU-011015020-106CL2P-H
10
6"-CRU-011015021-106CL2P-H
11
6"-CRU-011015022-106CL2P-H
11
6"-CRU-011015023-106CL2P-H
12
6"-CRU-011015024-106CL2P-H
12
6"-CRU-011015007-106CL2P-H
13
16"-CRU-011015007-106CL2P-H
13
8 7 6 5 SIGNAL
TO TY-0097 G
FROM FC-0015 E
FROM FC-0015 G
DS011-TRJR-480040
DS011-TRJR-480032
DS011-TRJR-480033
6078
5516
4068
4075
TOPPED CRUDE
TOPPED CRUDE
TOPPED CRUDE
TOPPED CRUDE
TOPPED CRUDE
FROM 011-E-0020
TO 011-F-0001
TO 011-F-0001
TO 011-F-0001
TO 011-F-0001
TO 011-F-0001
TO 011-F-0001
TO 011-F-0001
TO 011-F-0001
DS011-TRJR-480029 4062
DS011-TRJR-480033 5538
DS011-TRJR-480033 4148
DS011-TRJR-480032 5537
DS011-TRJR-480032 4143
DS011-TRJR-480031 5536
DS011-TRJR-480031 4078
DS011-TRJR-480030 5534
DS011-TRJR-480030 5533
SIGNAL
SIGNAL
SIGNAL
SIGNAL
SIGNAL
SIGNAL
SIGNAL
SIGNAL
TO TY-0097 C
FROM LY-0003
FROM TC-0097 A
FROM FC-0015 D
FROM FC-0015 A
TO TY-0097 F
TO TY-0097 H
FROM TC-0097 E
FROM FC-0015 F
FROM FC-0015 H
DS011-TRJR-480036
DS011-TRJR-480020
DS011-TRJR-480034
DS011-TRJR-480031
DS011-TRJR-480030
DS011-TRJR-480039
DS011-TRJR-480041
DS011-TRJR-480038
DS011-TRJR-480032
DS011-TRJR-480033
5493
3985
5508
4084
5542
5515
5517
6365
4072
4076
SIGNAL
SIGNAL
SIGNAL
SIGNAL
SIGNAL
SIGNAL
TO FC-0015 A
TO TY-0097 D
FROM TY-0097 B
FROM FC-0015 B
FROM FC-0015 C
TO FC-0015 E
DS011-TRJR-480030
DS011-TRJR-480037
DS011-TRJR-480035
DS011-TRJR-480030
DS011-TRJR-480031
DS011-TRJR-480032
5541
5494
6364
5544
4082
4066
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011(EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAIN SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
NOTES
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
3
SIGNAL
1
TOPPED CRUDE
4
SIGNAL
2
TOPPED CRUDE
SIGNAL
FROM LC-0003
3
TOPPED CRUDE
SIGNAL
DS011-TRJR-480020
4
TOPPED CRUDE
SIGNAL
05
13-MAR-2013
AB
04
30-SEP-2011
03
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
1
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
MMG / STG
RDP / MAC
JAL
REV
DATE
COMPANY STATUS
UTILITIES IDENTIFICATION POS.
2
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 CRUDE HEATER INLET ORIGINAL SIGNED IN PROJECT FILE
Item Tags :
011-075 011-080
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480311 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480311 2271-011-PID-0021-015
REV: 05
Sheet: 2 of 3
SCALE: NONE Format:
A1
41
41
40
40
39
39
38
38
37
37
36
36
35
35
34
34
33
OP
TY
33
0140 A
32
32
31
31
30
30
PASS 2
29
FC
FY
FC
FY
0033 A
0033 A
0033 B
0033 B
29
12"x6"
28
28
PASS 1
27
27
26
26
25
25
PASS 3 24
24
23
23
PASS 4
22
22
21
21
20
20
PASS 5 19
19
18
18
17
17
PASS 6
16
16
15
15
PASS 7 14
14
13
13
12
12
11
TI
11
0133
PASS 8
10 9 8
10
TT
9
2"
0133
8
7
7
6
6
6"-HFO-011027103-103CL4P-S
6"-HFO-011027113-103CL4P-S
6"-HFO-011027115-103CL4P-S
6"-HFO-011027116-103CL4P-S
6"-HFO-011027117-103CL4P-S
6"-HFO-011027118-103CL4P-S
1
6"-HFO-011027119-103CL4P-S
2
6"-HFO-011027120-103CL4P-S
3
12"-HFO-011027103-103CL4P-S
4
ATM RESIDUE
ATM RESIDUE
ATM RESIDUE
ATM RESIDUE
ATM RESIDUE
ATM RESIDUE
ATM RESIDUE
ATM RESIDUE
ATM RESIDUE
FROM 011-G-0014-A/B
TO 011-F-0002
TO 011-F-0002
TO 011-F-0002
TO 011-F-0002
TO 011-F-0002
TO 011-F-0002
TO 011-F-0002
TO 011-F-0002
DS011-TRJR-480066 5555
DS011-TRJR-480070 5556
DS011-TRJR-480070 5557
DS011-TRJR-480069 5558
DS011-TRJR-480069 5559
DS011-TRJR-480068 5560
DS011-TRJR-480068 5561
DS011-TRJR-480067 5562
DS011-TRJR-480067 5563
FROM HS-0005
SIGNAL FROM FC-0034 E
SIGNAL FROM FC-0034 G
DS011-TRJR-480076
DS011-TRJR-480044
DS011-TRJR-480069
DS011-TRJR-480070
5548
6136
4192
4196
4
SIGNAL TO TY-0140 E
SIGNAL TO TY-0140 G
SIGNAL TO TY-0140 H
SIGNAL FROM FC-0034 F
SIGNAL FROM FC-0034 H
DS011-TRJR-480075
DS011-TRJR-480077
DS011-TRJR-480078
DS011-TRJR-480069
DS011-TRJR-480070
5549
4189
4190
4194
4197
2 1
SIGNAL TO TY 0140 C
SIGNAL TO TY-0140 B
SIGNAL TO FC-0034 A
SIGNAL FROM FC-0034 C
SIGNAL FROM FC-0034 A
DS011-TRJR-480073
DS011-TRJR-480072
DS011-TRJR-480067
DS011-TRJR-480068
DS011-TRJR-480067
5522
5547
5550
5551
5553
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
SIGNAL TO TY-0140 D
SIGNAL FROM HS-0005
SIGNAL FROM TC-0140 A
SIGNAL FROM FC-0034 D
SIGNAL FROM FC-0034 B
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
DS011-TRJR-480074
DS011-TRJR-480044
DS011-TRJR-480071
DS011-TRJR-480068
DS011-TRJR-480067
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
5524
4178
5418
5552
5554
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
ARV / STG
RDP / MAC
JAL
PREPARED BY
CHECKED BY
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- ALL LINES CONNECTED TO CLOSED DRAINS SYSTEMS SHALL BE GRAVITY FLOW DESIGNED. 4- DRAIN VALVE ON EQUIPMENT AND/OR PIPING SHALL BE INSTALLED FLANGE TO FLANGE OR AT MINIMUM DISTANCE FROM THE EQUIPMENT/PIPING TO BE DRAINED.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
5
3
REV
NOTES
SIGNAL
SIGNAL TO TY-0140 F
5
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-078 Item Tags :
011-075 011-080
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 VACUUM HEATER INLET ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480312.pid
Discipline: PRO
SA-JER-DS011-TRJR-480312 2271-011-PID-0021-027
REV: 05
Sheet: 3 of 3
SCALE: NONE Format:
A1
011-RM-043-LC
011-RM-042-LC
011-RM-041-LC
011-RM-064-LC
011-RM-039-LC
38
011-RM-065-LC
39
011-RM-044-LC
40
011-RM-002-LC
40
011-RM-001-LC
41
011-RM-005-LC
41
N
39 38
TO LPC HEADER
DS011-TRJR-480204 5373 DS011-TRJR-480204 5365
LPC DS011-TRJR-480204 5367
DS011-TRJR-480204 5368
MPS
FROM MPS HEADER
FROM LPS HEADER
FROM DWA HEADER
DWA DS011-TRJR-480204 5364
FROM BFW HEADER
BFW LPS
23
20 19 18
16 15
LPS
FROM LPC HEADER
1-1/2"-LPC-011071742-101CS1P-H
1-1/2"-LPC-011071741-101CS1P-H
1-1/2"-LPC-011071743-101CS1P-H
MPC
24
17
DS011-TRJR-480204 5449
2"x1-1/2"
DS011-TRJR-480205 5461
FROM LPC HEADER TO MPS HEADER
25
21
2"-LPS-011071303-101CS1P-H
14 13 12
10
10 9
2"x1-1/2"
9
11
2"x1-1/2"
4"x2"
11
2"x1-1/2"
12
NOTE 1
28
22
12"-MPS-011071302-103CS1P-H
2"x1-1/2"
13
6"-LPC-011071301-101CS1P-H
2"x1-1/2"
LPS
14
29
26
D
3"-MPC-011071301-103CS1P-H
30
27
DS011-TRJR-480204 5369
DS011-TRJR-480205 5458
15
MPC
16
FROM MPC HEADER
18 17
6"-BFW-011071301-101CS1P-H
16"-LPS-011071301-101CS1P-H
MPS
19
2"-DWA-011071302-101SR0P-N
DS011-TRJR-480205 5459
20
TO LPS HEADER
LPS
21
DS011-TRJR-480205 5460
23 22
31
3/4"
LPC
24
32
D
DS011-TRJR-480205 5452
25
33
3/4"
UTIL.STATIONS HEADER
TO BFW HEADER
26
BFW
27
DS011-TRJR-480205 5462
28
34
TO MPC HEADER
DWA
29
DS011-TRJR-480205 5463
30
TO DWA HEADER
31
1-1/2"-LPC-011071764-101CS1P-H
32
1-1/2"-LPC-011071765-101CS1P-H
33
35
2"x1-1/2"
34
1-1/2"-LPC-011071701-101CS1P-H
35
1-1/2"-LPC-011071739-101CS1P-H
36
1-1/2"-LPC-011071744-101CS1P-H
36
1-1/2"-LPC-011071702-101CS1P-H
37
1-1/2"-LPC-011071705-101CS1P-H
37
8
8
1-1/2"-LPS-011071719-101CS1P-H
1-1/2"-LPS-011071720-101CS1P-H
1-1/2"-LPS-011071704-101CS1P-H
1-1/2"-LPS-011071713-101CS1P-H
2
1-1/2"-LPS-011071712-101CS1P-H
3
1-1/2"-LPS-011071707-101CS1P-H
4
1-1/2"-LPS-011071715-101CS1P-H
5
1-1/2"-LPS-011071708-101CS1P-H
6
1-1/2"-LPS-011071709-101CS1P-H
6
1-1/2"-LPS-011071705-101CS1P-H
7
1-1/2"-LPS-011071706-101CS1P-H
7
5 4 3 2
1
011-SM-019-LS
011-SM-020-LS
011-SM-004-LS
011-SM-013-LS
011-SM-012-LS
011-SM-007-LS
011-SM-015-LS
011-SM-008-LS
011-SM-009-LS
011-SM-005-LS
011-SM-006-LS
1
05
13-MAR-2013
AB
AB: AS BUILT
MJR / STG
AVS / HCR
JAL
04
30-SEP-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
MJR / STG
AVS / MAC
JAL
03
18-APR-2011
AFC
AFC: APPROVED FOR CONSTRUCTION
VSC / STG
AVS / MAC
JAL
02
22-DEC-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
IGR / STG
AVS / MAC
JAL
01
17-JUN-2010
AFC
AFC: APPROVED FOR CONSTRUCTION
JGT / STG
RDP / MAC
JAL
REV
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PRECEDED BY 011 (EX. 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022.
NOTES 1- FOR UTILITY STATIONS DRAWINGS REFER TO SA-JER-DS011-TRJR-480306 THROUGH 480310.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
COMPANY STATUS
REVISION MEMO
PREPARED BY
CHECKED BY
APPR/AUTH BY
REF. DWG
011-075 011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-076 011-075 011-080
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 MPS, LPS, LPC, BFW, CND, DWA, MPC UTILITY DISTRIBUTION ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480313.pid
Discipline: PRO
SA-JER-DS011-TRJR-480313 2271-011-PID-0021-071
REV:
05
Sheet: 7 of 7
SCALE: NONE Format:
A1
41
41
NOTE 1
40
NOTE 1
011-US-058
011-US-138
NOTE 1
NOTE 1
011-US-059
011-US-056
MI N.
NOTE 1
NOTE 1
011-US-055
011-US-135
40
N
39
36
S LP
RW
A
37
MIN.
MIN.
MIN.
MIN.
NC
38
NC
NC
1"x3/4"
2"x3/4"
1"x3/4" NC
37
NC
NC
38
1"x3/4"
1"x3/4"
1"x3/4"
39
36
I SA
L N2
29
1"-LPS-011071441-101CS1P-H
1"-RWA-011073438-301CG0W-N
1"-SAI-011074437-301CG2P-N
2"-LPS-011071359-101CS1P-H
0 15
DETAIL "A"
32
0 15
31 NC
30
X) MA E ( IN) D A M GR E( TO RAD 0 0 G O 12 0T 60 TE 6 NO
1"x¾"
ER EF R
28
LPS 6936 26 PID-480307
MIN. MIN.
25
RWA 6937 24 PID-480307
MIN.
2"-RWA-011073301-301CG0W-N
MIN.
23 6938 SAI PID-480307 22
MIN.
MIN.
3"-SAI-011074301-301CG2P-N
MIN.
4"-N2L-011074302-101CS1P-N
29
5
27
MIN. MIN. MIN.
MIN.
N2L 11727 PID-480308
3"-SAI-011074301-301CG2P-N
MIN.
MIN.
MIN.
23
SAI 11726 PID-480308 22
MIN.
2"-RWA-011073301-301CG0W-N
MIN.
MIN.
25
RWA 11725 PID-480308 24
MIN.
MIN.
TO
TE NO
2"-LPS-011071303-101CS1P-H
MIN.
2"-LPS-011071303-101CS1P-H
MIN.
MIN.
LPS
MIN.
45 °
26 11724 PID-480308
33
0 15
UTILITY STATION (STANDARD LAYOUT)
MIN.
27
20
MIN.
7 TE NO
MIN.
28
21
2"-RWA-011073357-301CG0W-N
2"-SAI-011074357-301CG2P-N
1"-LPS-011071361-101CS1P-H
1"-RWA-011073359-301CG0W-N
1"-SAI-011074359-301CG2P-N
1"-N2L-011074338-101CS1P-N
1"-LPS-011071364-101CS1P-H
1"-SAI-011074323-301CG2P-N
30
1"-LPS-011071444-101CS1P-H
31
1"-SAI-011074440-301CG2P-N
32
1"-LPS-011071363-101CS1P-H
1"-SAI-011074361-301CG2P-N
33
1"-RWA-011073362-301CG0W-N
34
1"-N2L-011074337-101CS1P-N
34
1"-RWA-011073441-301CG0W-N
35
1"-RWA-011073361-301CG0W-N
35
N2L 6939 PID-480307
4"-N2L-011074302-101CS1P-N
21 20
MIN. 19
19
18
18
MIN. MIN.
17
17
MIN. 2"x1"
16
16
MIN. 1"-LPS-011071344-101CS1P-H
15
15
MIN.
8
1"-N2L-011074340-101CS1P-N
2"-SAI-011074346-301CG2P-N
11 10 9 8 7 6 5 4
NOTE 1
NC
NC
3
1"x3/4"
011-US-057
011-US-040
011-US-038
011-US-054
NOTE 1
NOTE 1
NOTE 1
NOTE 1
NOTE 1
011-SC-0061
011-SC-0015
011-SC-0009
011-SC-0007
2
DS011-TRJR-480274
DS011-TRJR-480274
DS011-TRJR-480274
DS011-TRJR-480274
8276
8275
8274
8273
1
1"x3/4"
NC
2"x1"
2"x1"
011-US-139
2"x1"
12
011-US-137
1"x3/4"
1"x3/4"
2"-RWA-011073346-301CG0W-N
2"-LPS-011071348-101CS1P-H
1
MIN.
1"x3/4"
1"x3/4"
2
MIN.
NC
1"-SAI-011074360-301CG2P-N
1"-RWA-011073360-301CG0W-N
3
1"-LPS-011071362-101CS1P-H
4
NC
5
1"-SAI-011074441-301CG2P-N
6
1"-RWA-011073442-301CG0W-N
7
NC 1"-LPS-011071445-101CS1P-H
MIN.
13
1"x3/4"
MIN.
9
14
NC
1"-LPS-011071347-101CS1P-H
3/4"-RWA-011200306-301CG0W-N
10
1"-LPS-011071360-101CS1P-H
1"-RWA-011073345-301CG0W-N
3/4"-RWA-011200302-301CG0W-N
MIN. 11
3/4"-RWA-011200304-301CG0W-N
1"-SAI-011074345-301CG2P-N
3/4"-RWA-011200318-301CG0W-N
MIN. 12
1"-SAI-011074358-301CG2P-N
1"-SAI-011074342-301CG2P-N
13
1"-RWA-011073358-301CG0W-N
1"-N2L-011074339-101CS1P-N
MIN.
1"-SAI-011074439-301CG2P-N
1"-LPS-011071443-101CS1P-H
1"-RWA-011073342-301CG0W-N
14
1"-RWA-011073440-301CG0W-N
MIN.
00
011-US-039
REV
NOTE 1
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- HOSE CONNECTIONS SHALL BE DESIGN ACCORDING TO JERES-H-001 AND JERES-L-310.
NOTES 1- EACH UTILITY TAKE-OFF CONNECTION SHALL BE LOCATED AT THE TOP OF THE HORIZONTAL MAIN HEADER OR AUXILIARY HEADER. 2- RWA MAIN HEADER IS SHOWN ON PID: SA-JER-DS011-TRJR-480209. 3- LPS HEADER IS SHOWN ON PID: SA-JER-DS011-TRJR-480201 THROUGH-480206. 4- SAI AND N2L MAIN HEADER ARE SHOWN ON PID: SA-JER-DS011-TRJR-480211. 5- THE CONNECTORS AND COLOR CODING FOR HOSE CONNECTION SHALL BE STANDARDIZE AS FOLLOWS: UTILITY
HOSE CONNECTION
COLOR CODE
AIR
3/4 INCH IRON DIXON AIR KING AM-8
GREEN / GRAY STRIP
NITROGEN
1-INCH STEEL WING NUT UNION
GREEN / ORANGE STRIPE
RAW WATER
1-INCH BRASS AEROQUIP S101
BLUE
STEAM
1-INCH STEEL DIXON BOSS WF-36
WHITE
6- ELEVATION NOT HIGHER THAN 1200 mm ABOVE FINISHED PLANT GRADE OR ABOVE PLATFORM OF MULTILEVEL EQUIPMENT BUT NOT LOWER THAN 600 mm. 7- MINIMUM 150 mm CLEARANCE BETWEEN EACH OTHER.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
13-MAR-2013
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS.
011-073 011-072 011-073 011-071
011-071 011-071 011-071 011-071 011-071 011-074 011-074
19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
AB COMPANY STATUS
MJR / STG
AB: AS BUILT
REVISION MEMO
PREPARED BY
AVS / HCR
CHECKED BY
JAL
APPR/AUTH BY
REF. DWG
011-075
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM 011-078
Project:
011-074 011-078
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 UTILITY STATIONS No 6 ORIGINAL SIGNED IN PROJECT FILE
Item Tags :
011-075 011-080
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
Electronic Filename SA-JER-DS011-TRJR-480314 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480314 2271-011-PID-0021-261
REV: 00
Sheet: 6 of 7
SCALE: NONE Format:
A1
41
41
40 39
LPS
SAI
40
DS011-TRJR-480310 11759
DS011-TRJR-480310 11761
39
38
38
37 36
37
RWA
N2L
LPS
RWA
SAI
N2L
DS011-TRJR-480310 11760
DS011-TRJR-480310 11763
DS011-TRJR-480310 11767
DS011-TRJR-480310 11766
DS011-TRJR-480310 11765
DS011-TRJR-480310 11764
36
35
35
011-US-109
011-US-110
29
1"-N2L-011074373-101CS1P-N 1"x3/4"
MIN.
28
1"x3/4" 1"x3/4"
27 26 25
1"-N2L-011074357-101CS1P-N
1"-SAI-011074415-301CG2P-N
NC
24 23 22 21 20
1"x3/4"
NC
1"-LPS-011071415-101CS1P-H
1"-RWA-011073413-301CG0W-N
1"-SAI-011074412-301CG2P-N
1"-LPS-011071414-101CS1P-H
1"-RWA-011073412-301CG0W-N
1"-SAI-011074411-301CG2P-N
1"-LPS-011071413-101CS1P-H
1"-RWA-011073411-301CG0W-N
3/4"x1/4"
1"x3/4"
1"-RWA-011073422-301CG0W-N
NC
1"-LPS-011071425-101CS1P-H MIN.
1"x3/4"
NC
NC
1"x3/4"
1"x3/4" 1"-SAI-011074410-301CG2P-N
1"-N2L-011074316-101CS1P-N
1"-LPS-011071411-101CS1P-H
1"-RWA-011073409-301CG0W-N
1"-SAI-011074408-301CG2P-N
1"-N2L-011074314-101CS1P-N
3/4"-RWA-011200314-301CG0W-N
3/4"-RWA-011200316-301CG0W-N
1"-LPS-011071428-101CS1P-H
1"-RWA-011073425-301CG0W-N
1"-SAI-011074423-301CG2P-N
18
1"-N2L-011074364-101CS1P-N
19
2"-N2L-011074302-101CS1P-N
20
3"-SAI-011074301-301CG2P-N
21
2"-RWA-011073301-301CG0W-N
2"-LPS-011071303-101CS1P-H
22
NOTE 1
NOTE 1
NOTE 1
30
NOTE 1
011-US-108
32 31
011-US-132
NOTE 1
33
NC
MIN.
NOTE 1
011-US-120
011-US-119
23
1"x3/4"
1"x3/4"
NOTE 1
NC
1"x3/4"
1"x3/4"
NC
24
1"x3/4"
NC
1"x3/4"
25
011-US-131
1"x1"
MIN.
011-US-107
1"-RWA-011073429-301CG0W-N 1"-LPS-011071432-101CS1P-H
1"-N2L-011074367-101CS1P-N
1"-LPS-011071431-101CS1P-H MIN.
1"-N2L-011074369-101CS1P-N
7875
1"-SAI-011074428-301CG2P-N
NOTE 1
1"x1"
NC
26
1"-RWA-011073430-301CG0W-N
011-US-116
011-SC-0044
NOTE 1
27
DS011-TRJR-480275
7872
28
011-SC-0048
29
DS011-TRJR-480275
30
1"-LPS-011071433-101CS1P-H
MIN.
MIN.
1"-SAI-011074430-301CG2P-N
31
1"-RWA-011073428-301CG0W-N
1"x3/4"
1"-SAI-011074426-301CG2P-N
MIN.
1"-SAI-011074427-301CG2P-N
1"-SAI-011074434-301CG2P-N
1"-RWA-011074432-301CG0W-N
MIN.
MIN.
MIN.
1"-RWA-011073435-301CG0W-N
1"-LPS-011071435-101CS1P-H
1"-LPS-011071438-101CS1P-H
MIN.
34
MIN.
MIN.
NC
MIN.
011-US-114
19 18
011-US-129
16
2"-N2L-011074316-101CS1P-N
MIN.
2"x1"
12
NOTE 1
2"x1"
011-US-111
MIN.
MIN.
MIN.
MIN.
2"-LPS-011071426-101CS1P-H
1"x3/4"
2"x1"
MIN.
MIN.
MIN.
2"-RWA-011073423-301CG0W-N
MIN.
MIN.
13
15
2"-SAI-011074421-301CG2P-N
MIN.
MIN.
MIN.
15 14
2"x1"
MIN.
MIN.
MIN.
MIN.
16
17
NOTE 1
MIN.
17
MIN.
32
NOTE 1
33
1"x1"
1"-N2L-011074368-101CS1P-N
34
14 13 12
NC
11
11
10
10 MI N.
MIN.
9
1"-RWA-011073431-301CG0W-N MIN.
1"x3/4"
8
1"-SAI-011074429-301CG2P-N MIN. MIN.
6
S LP
5
MIN. 1"-RWA-011200323-301CG0W-N
4
RW
A
MIN.
7
1"-N2L-011074370-101CS1P-N
MIN.
7
MIN. 1"-LPS-011071434-101CS1P-H
MIN.
8
NOTE 1
9
011-US-117
NC
I SA
6 5
L N2
011-SC-0025
4
DS011-TRJR-480274 7873
3
3
NC
2
7 TE NO
MIN. 1"-LPS-011071436-101CS1P-H
011-US-113
NOTE 1
1
1"x3/4"
0 15
DETAIL "A"
1"-RWA-011073433-301CG0W-N
2
0 15
UTILITY STATION (STANDARD LAYOUT)
MIN.
0 15
MIN.
1
1"-SAI-011074431-301CG2P-N NC
MIN.
X) MA E ( IN) D A M GR E( TO RAD 0 0 G O 12 0T 60 TE 6 NO
1"-N2L-011074371-101CS1P-N
1"x¾"
45°
GENERAL NOTES 1- EACH INSTRUMENT TAG NUMBER IS PREFIXED BY 011 (EX 011-TT-0001). 2- FOR GENERAL NOTES, SYMBOLS AND DETAILS SEE DRAWINGS SA-JER-DSAAA-TRJR-480001 THROUGH SA-JER-DSAAA-TRJR-480022. 3- HOSE CONNECTIONS SHALL BE DESIGN ACCORDING TO JERES-H-001 AND JERES-L-310.
NOTES 1- EACH UTILITY TAKE-OFF CONNECTION SHALL BE LOCATED AT THE TOP OF THE HORIZONTAL MAIN HEADER OR AUXILIARY HEADER.
This document is the property of SATORP and shall not be disclosed to third parties or reproduced without permission of the owner.
ER EF R
TO
TE NO
5
00
13-MAR-2013
REV
DATE
UTILITIES IDENTIFICATION POS. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
DESCRIPTION FIRE WATER SERVICE WATER COOLING WATER POTABLE WATER DEMI WATER N.A. N.A. N.A. HP STEAM MP STEAM LP STEAM HP CONDENSATE MP CONDENSATE LP CONDENSATE BFW PLANT AIR INSTRUMENT AIR N.A.
REF. DWG POS. 19 20 21 22 23 24 25 26 27 28 29 30 31 32
DESCRIPTION N.A. FUEL OIL FUEL GAS N.A. N.A. N.A. CLOSED DRAIN N.A. L.P. NITROGEN H.P. FLARE L.P. FLARE SOUR/ACID FLARE PILOT GAS AUX COOLING WATER
AB
MJR /STG
AB: AS BUILT
COMPANY STATUS
REVISION MEMO
PREPARED BY
AVS/HCR CHECKED BY
JAE APPR/AUTH BY
REF. DWG
JUBAIL EXPORT REFINERY PIPING AND INSTRUMENT DIAGRAM Project:
Item Tags :
Syst./ S-Syst.:
COMPANY Document N° Contractor/Vendor Document N°
DISTILLATION AND HYDROTREATING CRUDE DISTILLATION UNIT TRAIN 1 UTILITY STATIONS No 7 ORIGINAL SIGNED IN PROJECT FILE Electronic Filename SA-JER-DS011-TRJR-480315 .pid
Discipline: PRO
SA-JER-DS011-TRJR-480315 2271-011-PID-0021-261
REV: 00
Sheet: 7 of 7
SCALE: NONE Format:
A1
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 5.
PROCESS MATERIAL BALANCE Document Number SA-JER-DS011-TRJR-290001
Description HEAT AND MATERIAL BALANCE
Rev. 03
P.O DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 1 of 193
ORIGINAL SIGNED IN PROJECT FILE
HEAT AND MATERIAL BALANCE CDU/VDU UNIT (UNIT 011)
This document is also valid for the unit 012. Changes have been highlighted with a vertical line on the left side.
REVISION CONTROL REV. 03 02 01 00
DATE 12-MAY-2011 10-DEC-2010 06-AUG-2010 08-JAN-2010
DESCRIPTION Approved for Construction Approved for Construction Approved for Construction Issue for Acceptance
DISCIPLINE CODE
DOCUMENT TYPE
UNIT
PRO
SPE
011
SYSTEM
Document class: 1 PREPARED BY
CHECKED BY
APPROVED BY
Sara Hidalgo
Miguel Angel Castro / José L. Roldán
Juan Lechuga
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 2 of 193
INDEX
1.
MASS BALANCE (DRY BASIS) & TBP CUTPOINTS
3
2.
PSEUDO‐COMPONENTS PROPERTIES
4
3.
BASE CASE
6
3.1. BASE CASE. FEED HEAT AND MATERIAL BALANCE 3.1.1. STREAMS COMPOSITIONS – BASE CASE. FEED HEAT AND MATERIAL BALANCE 3.1.2. PHYSICAL PROPERTIES – BASE CASE. FEED HEAT AND MATERIAL BALANCE 3.2. BASE CASE. EPCC HEAT AND MATERIAL BALANCE 3.2.1. STREAMS COMPOSITIONS – BASE CASE. EPCC HEAT AND MATERIAL BALANCE 3.2.2. PHYSICAL PROPERTIES – BASE CASE. EPCC HEAT AND MATERIAL BALANCE
6 6 11 15 15 50
4.
DISTILLATION CURVES
70
5.
MAXI KEROSENE CASE
71
5.1. 5.2. 6.
112
MAXI NAPHTHA CASE 6.1. 6.2.
7.
71 92
STREAM COMPOSITIONS – MAXI KEROSENE CASE PHYSICAL PROPERTIES – MAXI KEROSENE CASE
112 133
STREAM COMPOSITIONS – MAXI NAPHTHA CASE PHYSICAL PROPERTIES – MAXI NAPHTHA CASE
153
KEROSENE IN DIESEL POOL CASE CASE 7.1. 7.2.
153 174
STREAM COMPOSITIONS – KEROSENE IN DIESEL POOL CASE CASE PHYSICAL PROPERTIES – KEROSENE IN DIESEL POOL CASE
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
1.
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 3 of 193
MASS BALANCE (DRY BASIS) & TBP CUTPOINTS
An overall heat and material balance (dry basis) with TBP cut points for Base Case, Maxi Naphtha Case, Maxi Kerosene Case and case when kerosene is sent to diesel pool is shown in this section. The material balance is for one CDU/VDU train. BASE CASE
Description ATMOSPHERIC DISTILLATION Flow in Crude Naphtha from LP & HP HDS units ** Total
t/h t/h t/h
1179.3 8.5 1187.8
Total
t/h t/h t/h t/h t/h t/h t/h t/h
77.8 74.3 152.1 133.5 120.2 108.8 673.2 1187.8
Flow out & TBP cut points Preflash naphtha Naphtha Total naphtha * Kerosene * Light Atm Gasoil Heavy Atm Gasoil Atm resid
VACUUM DISTILLATION Flow in Atmospheric residu Air
IP - 145 145 - 230 230 - 300 300 - 360 360 +
MAX KERO
66.8 144.6 140.9
BASE CASE
BASE CASE
1.3% 1 wt cracked gasoil
no cracked gasoil
Total
t/h t/h t/h
673.2 0.05 673.25
673.2 0.05 673.25
Total
t/h t/h t/h t/h t/h t/h t/h
0.75 6.7 33.2 102.0 181.5 349.1 673.25
0.85 0.2 32.3 99.2 182.5 358.2 673.25
Flow out & TBP cut points Vent gas Recovered oil LVGO MVGO HVGO Vacuum residu
IP - 140 140 - 230
360 - 379 379 - 442 442 - 550 550 +
MAX NAPHTHA
96.8 174.6 110.9
IP - 160 160 - 230
KERO in DIESEL
360 - 379 379 - 441 441 - 550 550 +
0.75 6.6 41.6 103.7 171.5 349.1 673.25
360 - 383 383 - 448 448 - 550 550 +
(*) Total naphtha flow includes 7 t/h from the wild naphtha stream, kerosene flow includes 1.5 t/h from the wild naphtha stream. (**) Maximum wild naphtha flowrate is 10.8 t/h (9.5 t/h of naphtha and 1.3 t/h of kerosene). Unit is designed for processing variable naphtha flow as defined in Unit Basis of Design (document number SA-JER-DS011-TRJR320001, appendix 5).
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
2.
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 4 of 193
PSEUDO-COMPONENTS PROPERTIES
The properties of each pseudo-component (Boiling point, molecular weight and density) are presented in this section: COMPONENT --------------------1 H2O 2 H2S 3 N2 4 H2 5 NH3 6 AIR 7 CO2 8 METHANE 9 ETHANE 10 PROPANE 11 PROPENE 12 IBUTANE 13 BUTANE 14 BUTENE-1 15 IPENTANE 16 PENTANE 17 NBP 38 18 NBP 45 19 NBP 55 20 NBP 65 21 NBP 75 22 NBP 85 23 NBP 95 24 NBP 105 25 NBP 115 26 NBP 125 27 NBP 135 28 NBP 145 29 NBP 155 30 NBP 165 31 NBP 175 32 NBP 185 33 NBP 195 34 NBP 205 35 NBP 215 36 NBP 225 37 NBP 235 38 NBP 245 39 NBP 255 40 NBP 265 41 NBP 275 42 NBP 285 43 NBP 295 44 NBP 305 45 NBP 315 46 NBP 325 47 NBP 335 48 NBP 345 49 NBP 355 50 NBP 365 51 NBP 375 52 NBP 385 53 NBP 395 54 NBP 405 55 NBP 415 56 NBP 425 57 NBP 435 58 NBP 445 59 NBP 455
COMP. TYPE ----------LIBRARY LIBRARY LIBRARY LIBRARY LIBRARY LIBRARY LIBRARY LIBRARY LIBRARY LIBRARY LIBRARY LIBRARY LIBRARY LIBRARY LIBRARY LIBRARY ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT ASSAY CUT
PHASE ----------VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ
MOL. WEIGHT ----------18.015 34.079 28.013 2.016 17.031 28.972 44.010 16.043 30.070 44.097 42.081 58.124 58.124 56.108 72.151 72.151 71.000 74.400 79.300 84.100 88.903 93.700 98.700 103.800 109.102 114.502 120.000 125.700 131.300 137.300 143.502 150.002 156.500 163.203 170.003 177.100 184.403 191.803 199.500 207.403 215.600 224.103 232.500 241.200 250.100 259.203 268.300 278.000 288.000 298.503 309.304 320.604 332.504 344.700 357.405 370.700 384.605 397.500 412.407
DENSITY KG/M3 ----------998.566 789.281 807.313 69.931 618.262 871.096 826.185 299.704 356.049 507.199 521.485 562.545 583.824 600.707 622.112 630.378 633.974 647.361 664.644 679.629 692.427 702.906 703.805 713.096 722.191 731.282 740.169 749.161 760.150 767.842 773.837 777.835 784.526 791.821 798.814 805.605 811.801 818.295 824.786 830.882 836.474 841.971 848.962 856.055 862.948 869.844 878.133 884.527 890.521 896.117 901.312 906.007 910.203 914.198 917.795 920.891 923.692 930.182 932.479
NBP C ----------100.000 -60.340 -195.800 -252.800 -33.400 -194.360 -78.480 -161.490 -88.630 -42.070 -47.700 -11.730 -0.500 -6.300 27.850 36.074 38.000 45.000 55.000 65.000 75.000 85.000 95.000 105.000 115.000 125.000 135.000 145.000 155.000 165.000 175.000 185.000 195.000 205.000 215.000 225.000 235.000 245.000 255.000 265.000 275.000 285.000 295.000 305.000 315.000 325.000 335.000 345.000 355.000 365.000 375.000 385.000 395.000 405.000 415.000 425.000 435.000 445.000 455.000
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 5 of 193
60
NBP
470
ASSAY CUT
VAP/LIQ
436.600
933.778
470.000
61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77
NBP NBP NBP NBP NBP NBP NBP NBP NBP NBP NBP NBP NBP NBP NBP NBP NBP
490 510 530 550 570 590 610 630 660 700 740 780 820 860 900 940 980
ASSAY ASSAY ASSAY ASSAY ASSAY ASSAY ASSAY ASSAY ASSAY ASSAY ASSAY ASSAY ASSAY ASSAY ASSAY ASSAY ASSAY
VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ VAP/LIQ
465.606 501.007 536.800 573.303 612.100 653.900 695.351 735.603 792.636 866.493 938.013 1008.262 1077.343 1145.825 1215.432 1286.988 1360.492
947.265 950.663 957.954 968.445 978.534 987.825 997.279 1006.672 1020.307 1038.478 1056.567 1074.778 1093.740 1113.040 1133.130 1154.236 1176.359
490.000 510.000 530.000 550.000 570.000 590.000 610.000 630.000 660.000 700.000 740.000 780.000 820.000 860.000 900.000 940.000 980.000
CUT CUT CUT CUT CUT CUT CUT CUT CUT CUT CUT CUT CUT CUT CUT CUT CUT
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
3.
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 6 of 193
BASE CASE
The heat and material balance for the Base Case (Naphtha/Kerosene cut point = 145°C) is included in this section. Stream numbers correspond to the streams identified in the Process Flow Diagrams: SA-JER-DS011-TRJR-450001, SA-JER-DS011-TRJR-450020, SA-JER-DS011-TRJR-450002, SA-JER-DS011-TRJR-450003, SA-JER-DS011TRJR-450021, SA-JER-DS011-TRJR-450022 and SA-JER-DS011-TRJR-450038. First, the heat and material balance for the main streams of the unit are included. In fact, this is the heat and material balance produced in the FEED stage of the project with some minor comments. Next, information for the main streams as well as for additional streams are also shown, as a result of the heat and material balance performed in the EPCC phase of the project. Two types of summaries are given, one showing the composition and the other showing the physical properties. The first summary does not include all the streams shown in the PFD, but only those where there is a change in the compostition.
3.1.
BASE CASE. FEED HEAT AND MATERIAL BALANCE
Composition and physical properties for the main streams are shown in this section. Data Sheet for specification of the equipments, instrumentation, lines, etc, are based on this heat and material balance. Data sheet for specification of the equipments, instrumentation, lines, etc, are based on this heat and material balance.
3.1.1.
STREAMS COMPOSITIONS – BASE CASE. FEED HEAT AND MATERIAL BALANCE
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM ID NAME
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 7 of 193
N°1 Crude
N°2 Wild naphtha
N°3 Total naphtha
N°4 Kerosene to LP HDS
N°5 Kerosene to storage
N°6 LAGO to LP HDS
N°7 LAGO to storage
FLUID RATES, KG/HR 1 H2O 9 ETHANE 11 PROPANE 13 IBUTANE 14 BUTANE 16 IPENTANE 17 PENTANE 18 NBP 38 19 NBP 45 20 NBP 55 21 NBP 65 22 NBP 75 23 NBP 85 24 NBP 95 25 NBP 105 26 NBP 115 27 NBP 125 28 NBP 135 29 NBP 145 30 NBP 155 31 NBP 165 32 NBP 175 33 NBP 185 34 NBP 195 35 NBP 205 36 NBP 215 37 NBP 225 38 NBP 235 39 NBP 245 40 NBP 255 41 NBP 265 42 NBP 275 43 NBP 285 44 NBP 295 45 NBP 305 46 NBP 315 47 NBP 325 48 NBP 335 49 NBP 345 50 NBP 355 51 NBP 365 52 NBP 375 53 NBP 385 54 NBP 395 55 NBP 405 56 NBP 415 57 NBP 425 58 NBP 435 59 NBP 445 60 NBP 455 61 NBP 470 62 NBP 490 63 NBP 510 64 NBP 530 65 NBP 550 66 NBP 570 67 NBP 590 68 NBP 610 69 NBP 630 70 NBP 660 71 NBP 700 72 NBP 740 73 NBP 780 74 NBP 820 75 NBP 860 76 NBP 900 77 NBP 940 78 NBP 980
0.0000 344.2932 5200.0144 2338.8193 10364.4123 7242.0292 13166.2466 1816.0450 4764.1700 5400.9650 6438.7050 7842.0125 9386.8300 10613.2500 11816.0850 12842.0325 13691.0925 14339.6800 14811.3800 15188.7400 15424.5900 15530.7225 15530.7225 15518.9300 15601.4775 15766.5725 16014.2150 16356.1975 16686.3875 16981.2000 17252.4275 17452.9000 17653.3725 17830.2600 17971.7700 18089.6950 18172.2425 18231.2050 18207.6200 18066.1100 17771.2975 17346.7675 16875.0675 16426.9525 16037.8000 15672.2325 15377.4200 15106.1925 14952.8900 14799.5875 29622.7600 32181.7325 34186.4575 33136.9250 49799.7275 21250.0850 20613.2900 19711.4476 18406.6662 33992.6685 31335.1266 29495.1513 28172.6432 26720.8314 26078.2151 26078.2151 26078.2151 26078.2151
0.0000 0.0000 127.5000 99.2000 283.3000 212.5000 283.3000 474.5000 297.4000 311.6000 344.4000 400.2000 474.7000 569.6000 674.2000 775.8000 828.7000 644.3000 437.8000 328.7000 266.9000 228.6000 169.4000 102.8000 80.5000 81.1000 3.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000
58.9149 344.2848 5327.3849 2437.9582 10647.4400 7454.2454 13448.9446 2290.4371 5061.2217 5711.9082 6781.6690 8238.5436 9850.4832 11147.4786 12357.5254 13143.5223 13100.3106 11600.3126 8338.0911 3738.5657 881.1095 142.3185 19.7067 2.6019 0.3410 0.0402 4.5281E-03 4.5980E-04 3.7985E-05 2.1301E-06 7.2060E-08 1.6289E-09 2.9098E-11 4.5487E-13 6.2852E-15 8.3179E-17 1.4787E-18 4.3096E-20 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000
1.3387E-08 1.9376E-12 2.0990E-08 1.4347E-06 1.6915E-05 9.4728E-04 3.7070E-03 1.1712E-03 6.9684E-03 0.0345 0.1804 0.9624 4.9926 22.1933 100.3792 390.2037 1209.2704 2921.9847 6001.6844 10224.4919 12734.0371 13168.4150 12833.0875 12239.9161 11550.6766 10690.6150 9437.3056 7750.2961 5316.0290 2554.7254 768.1829 160.5350 27.3816 4.0779 0.5217 0.0520 3.3957E-03 1.3565E-04 3.7509E-06 8.2106E-08 1.5133E-09 2.3333E-11 2.8929E-13 2.7457E-15 1.9655E-17 1.0908E-19 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000
1.4874E-09 2.1529E-13 2.3322E-09 1.5941E-07 1.8795E-06 1.0525E-04 4.1189E-04 1.3013E-04 7.7427E-04 3.8384E-03 0.0200 0.1069 0.5547 2.4659 11.1532 43.3560 134.3634 324.6649 666.8538 1136.0546 1414.8929 1463.1571 1425.8985 1359.9906 1283.4084 1187.8460 1048.5894 861.1439 590.6698 283.8584 85.3536 17.8372 3.0424 0.4531 0.0580 5.7755E-03 3.7730E-04 1.5073E-05 4.1677E-07 9.1229E-09 1.6815E-10 2.5925E-12 3.2143E-14 3.0508E-16 2.1839E-18 1.2120E-20 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000
117.1298 2.5285E-07 1.6821E-04 1.4001E-03 0.0106 0.0799 0.2143 0.0403 0.1730 0.3838 0.8614 1.9416 4.2888 8.5663 17.3111 33.7107 63.3998 115.2728 204.7784 353.6477 558.8304 830.7645 1194.2254 1688.6174 2367.7165 3281.3661 4545.7339 6332.6014 8773.4769 11394.6680 12862.3386 12877.6597 12112.0266 10757.7102 8666.6265 5688.5473 2548.6732 722.2516 148.1539 25.0559 3.7039 0.4762 0.0513 4.4215E-03 2.9978E-04 1.6499E-05 7.7938E-07 3.2825E-08 1.3032E-09 4.6638E-11 5.4315E-13 5.6331E-16 3.7535E-19 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000
13.0144 2.8094E-08 1.8691E-05 1.5557E-04 1.1745E-03 8.8820E-03 0.0238 4.4783E-03 0.0192 0.0426 0.0957 0.2157 0.4765 0.9518 1.9235 3.7456 7.0444 12.8081 22.7532 39.2942 62.0923 92.3072 132.6917 187.6242 263.0796 364.5962 505.0816 703.6224 974.8308 1266.0742 1429.1488 1430.8511 1345.7808 1195.3011 962.9585 632.0608 283.1859 80.2502 16.4615 2.7840 0.4115 0.0529 5.7017E-03 4.9127E-04 3.3309E-05 1.8332E-06 8.6598E-08 3.6472E-09 1.4480E-10 5.1820E-12 6.0350E-14 6.2590E-17 4.1706E-20 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000
TOTAL RATE, KG/HR
1.1792E+06
8500.0000
152125.3647
120112.2482
13345.8043
108303.0922
12033.6771
40.0000 2.0000 19.4689 248.5450 0.0000 1.0000 1.0000 0.0000
70.0000 5.0000 0.1928 95.5819 0.0000 1.0000 1.0000 0.0000
43.0000 7.0000 3.3702 86.0674 0.0000 1.0000 1.0000 0.0000
70.0000 7.0000 2.2044 152.3498 0.0000 1.0000 1.0000 0.0000
43.0000 7.0000 0.2449 152.3498 0.0000 1.0000 1.0000 0.0000
50.0000 7.0000 2.1106 203.4632 0.0000 1.0000 0.9992 7.9488E-04
50.0000 7.0000 0.2345 203.4632 0.0000 1.0000 0.9992 7.9488E-04
TEMPERATURE, C PRESSURE, BAR(GA) ENTHALPY, M*KCAL/HR MOLECULAR WEIGHT WEIGHT FRAC VAPOR WEIGHT FRAC TOTAL LIQUID WEIGHT FRAC H/C LIQUID WEIGHT FRAC FREE WATER
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM ID NAME
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 8 of 193
N°8 HAGO to HP HDS
N°9 HAGO to storage
N°10 LVGO to HP HDS
N°11 LVGO to storage
N°12 HVGO to DHC/MHC
N°13 HVGO to storage
N°14 Vac Res to storage
FLUID RATES, KG/HR 1 H2O 2 H2S 4 H2 6 AIR 8 METHANE 9 ETHANE 10 ETHYLENE 11 PROPANE 12 PROPENE 13 IBUTANE 14 BUTANE 15 BUTENE-1 16 IPENTANE 17 PENTANE 18 NBP 38 19 NBP 45 20 NBP 55 21 NBP 65 22 NBP 75 23 NBP 85 24 NBP 95 25 NBP 105 26 NBP 115 27 NBP 125 28 NBP 135 29 NBP 145 30 NBP 155 31 NBP 165 32 NBP 175 33 NBP 185 34 NBP 195 35 NBP 205 36 NBP 215 37 NBP 225 38 NBP 235 39 NBP 245 40 NBP 255 41 NBP 265 42 NBP 275 43 NBP 285 44 NBP 295 45 NBP 305 46 NBP 315 47 NBP 325 48 NBP 335 49 NBP 345 50 NBP 355 51 NBP 365 52 NBP 375 53 NBP 385 54 NBP 395 55 NBP 405 56 NBP 415 57 NBP 425 58 NBP 435 59 NBP 445 60 NBP 455 61 NBP 470 62 NBP 490 63 NBP 510 64 NBP 530 65 NBP 550 66 NBP 570 67 NBP 590 68 NBP 610 69 NBP 630 70 NBP 660 71 NBP 700 72 NBP 740 73 NBP 780 74 NBP 820 75 NBP 860 76 NBP 900 77 NBP 940 78 NBP 980
89.4777 0.0000 0.0000 0.0000 0.0000 9.6521E-08 0.0000 3.9054E-05 0.0000 2.5259E-04 1.7232E-03 0.0000 0.0108 0.0276 5.1148E-03 0.0210 0.0440 0.0942 0.2006 0.4104 0.7664 1.4040 2.4638 4.2012 7.1443 12.2480 20.9915 33.8442 52.4543 79.8318 120.9847 183.2732 272.8381 403.9237 591.8487 853.8954 1212.9212 1700.8952 2355.5643 3251.1411 4504.7219 6313.0691 8818.9013 11261.3608 12144.5840 11508.9306 10077.1467 8246.7632 6160.1301 4018.9782 2179.9380 966.4493 361.6258 120.9659 37.5948 11.1415 3.1914 0.9324 0.0708 4.6256E-03 2.4959E-04 1.9336E-05 3.9116E-07 1.6564E-08 6.4843E-10 2.3428E-11 3.0155E-13 3.4853E-16 4.4443E-19 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000
9.9420 0.0000 0.0000 0.0000 0.0000 1.0724E-08 0.0000 4.3393E-06 0.0000 2.8065E-05 1.9147E-04 0.0000 1.1976E-03 3.0714E-03 5.6831E-04 2.3337E-03 4.8917E-03 0.0105 0.0223 0.0456 0.0852 0.1560 0.2738 0.4668 0.7938 1.3609 2.3324 3.7605 5.8283 8.8702 13.4427 20.3637 30.3153 44.8804 65.7610 94.8773 134.7690 188.9883 261.7294 361.2379 500.5246 701.4521 979.8779 1251.2622 1349.3981 1278.7700 1119.6829 916.3070 684.4589 446.5531 242.2153 107.3833 40.1806 13.4407 4.1772 1.2379 0.3546 0.1036 7.8718E-03 5.1396E-04 2.7732E-05 2.1484E-06 4.3462E-08 1.8405E-09 7.2048E-11 2.6031E-12 3.3506E-14 3.8726E-17 4.9381E-20 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000
2.4924 0.0218 5.0243E-06 1.2545E-03 1.7798E-03 4.1384E-03 5.8992E-04 0.0141 4.8746E-03 5.9608E-03 0.0359 0.0119 0.0316 0.0611 4.5670E-07 2.0935E-06 5.2041E-06 1.3429E-05 3.5113E-05 8.9866E-05 2.1238E-04 5.0859E-04 1.1932 2.6456 5.1997 9.0858 17.1089 30.3900 52.9600 76.7944 112.9261 167.9911 228.6048 270.0531 302.9154 340.0376 342.1523 347.6486 398.7796 536.4545 762.9186 1102.6107 1614.7808 2267.6324 3054.5158 3883.5085 4649.8675 4843.8871 3334.3920 975.1523 146.6234 16.6860 1.6372 0.1450 0.0118 8.8867E-04 6.2103E-05 2.0330E-06 7.1902E-09 1.8837E-11 3.3371E-14 6.5509E-17 2.4865E-20 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000
0.2751 2.4067E-03 5.5453E-07 1.3846E-04 1.9643E-04 4.5675E-04 6.5108E-05 1.5597E-03 5.3800E-04 6.5788E-04 3.9585E-03 1.3143E-03 3.4917E-03 6.7483E-03 5.0405E-08 2.3106E-07 5.7436E-07 1.4822E-06 3.8754E-06 9.9183E-06 2.3440E-05 5.6132E-05 0.1317 0.2920 0.5739 1.0028 1.8883 3.3541 5.8451 8.4756 12.4634 18.5408 25.2306 29.8052 33.4321 37.5293 37.7626 38.3693 44.0125 59.2074 84.2018 121.6929 178.2200 250.2739 337.1206 428.6148 513.1963 534.6098 368.0100 107.6255 16.1825 1.8416 0.1807 0.0160 1.2996E-03 9.8081E-05 6.8542E-06 2.2437E-07 7.9356E-10 2.0790E-12 3.6831E-15 7.2301E-18 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000
6.8982 0.0406 2.2568E-05 5.6355E-03 7.9951E-03 0.0104 1.7310E-03 0.0277 9.0763E-03 9.4577E-03 0.0523 0.0183 0.0385 0.0660 4.6751E-07 1.9874E-06 4.4140E-06 1.0109E-05 2.3273E-05 5.1943E-05 1.0580E-04 2.1522E-04 0.4213 0.7628 1.1939 1.6156 2.2902 2.9851 3.7504 3.9052 4.1918 4.7476 5.2672 5.5333 6.0396 7.1375 8.0323 9.5315 13.1643 21.8050 38.8679 71.5335 135.5458 250.7581 455.4826 810.1710 1467.2124 2861.0848 6096.4569 10198.4972 12472.2567 13466.2627 13754.5170 13725.6510 13554.6792 13424.5562 13261.2266 26337.1503 27802.6053 27362.9765 22417.7366 24788.3568 6422.2139 2842.5634 843.8847 171.0913 21.5880 0.3932 5.6838E-03 6.6596E-05 6.2163E-07 4.7947E-09 3.0436E-11 1.5518E-13 4.0000E-16
0.7665 4.5113E-03 2.5076E-06 6.2617E-04 8.8834E-04 1.1580E-03 1.9233E-04 3.0751E-03 1.0085E-03 1.0509E-03 5.8142E-03 2.0387E-03 4.2726E-03 7.3336E-03 5.1945E-08 2.2083E-07 4.9044E-07 1.1232E-06 2.5859E-06 5.7715E-06 1.1756E-05 2.3913E-05 0.0468 0.0848 0.1327 0.1795 0.2545 0.3317 0.4167 0.4339 0.4658 0.5275 0.5852 0.6148 0.6711 0.7931 0.8925 1.0591 1.4627 2.4228 4.3187 7.9482 15.0606 27.8620 50.6092 90.0190 163.0236 317.8983 677.3841 1133.1663 1385.8063 1496.2514 1528.2796 1525.0723 1506.0754 1491.6173 1473.4696 2926.3499 3089.1783 3040.3306 2490.8595 2754.2618 713.5793 315.8404 93.7650 19.0101 2.3987 0.0437 6.3153E-04 7.3995E-06 6.9070E-08 5.3274E-10 3.3817E-12 1.7242E-14 4.4444E-17
0.0827 8.1492E-11 1.3845E-17 0.6202 4.3569E-12 8.4152E-12 1.2287E-12 1.0124E-10 1.8217E-11 7.0566E-11 5.1942E-10 1.6017E-10 8.0233E-10 1.4029E-09 1.7653E-14 7.8059E-14 1.8496E-13 4.5641E-13 1.1430E-12 2.8012E-12 6.3225E-12 1.4377E-11 3.1735E-08 6.5324E-08 1.1716E-07 1.8309E-07 3.0191E-07 4.6105E-07 6.8325E-07 8.4468E-07 1.0832E-06 1.4746E-06 1.9779E-06 2.5262E-06 3.3708E-06 4.8956E-06 6.8058E-06 1.0026E-05 1.7274E-05 3.5856E-05 8.0435E-05 1.8700E-04 4.4893E-04 1.0540E-03 2.4272E-03 5.4268E-03 0.0120 0.0258 0.0544 0.1125 0.2242 0.4270 0.7831 1.4140 2.5396 4.5867 8.2604 40.0378 133.4109 382.5964 826.1940 2229.0506 1412.0553 1745.4447 1876.9774 1821.1621 3395.8987 3132.5715 2948.6697 2816.4574 2671.3178 2607.0746 2607.0746 2607.0746 1640.8612
TOTAL RATE, KG/HR
97989.4295
10887.7138
29899.9992
3300.0011
255164.8865
28351.6531
34913.0814
TEMPERATURE, C PRESSURE, BAR(GA) ENTHALPY, M*KCAL/HR MOLECULAR WEIGHT WEIGHT FRAC VAPOR WEIGHT FRAC TOTAL LIQUID WEIGHT FRAC H/C LIQUID WEIGHT FRAC FREE WATER
50.0000 7.5000 1.7226 260.2564 0.0000 1.0000 0.9994 6.1074E-04
50.0000 7.5000 0.1914 260.2564 0.0000 1.0000 0.9994 6.1074E-04
50.0000 7.5000 0.5221 266.2418 0.0000 1.0000 1.0000 0.0000
50.0000 7.5000 0.0576 266.2418 0.0000 1.0000 1.0000 0.0000
160.0000 11.5000 17.9688 423.1820 0.0000 1.0000 1.0000 0.0000
90.0000 7.0000 0.9617 423.1820 0.0000 1.0000 1.0000 0.0000
180.0000 7.0000 2.6653 856.5277 0.0000 1.0000 1.0000 0.0000
Note 1 : Depending on cracked gasoil in vacuum heater, vacuum residue flow can vary from 358.2 to 349.1 t/h
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM ID NAME
N°15 Vac Res to DCU
REV: 03 Date: 12-MAY-11 N°16 N°17 Preflash Naphtha from overhead preflash
TR Project No.: 02020 Page 9 of 193
N°18 CDU feed
N°19 CDU overhead
N°20 Atmospheric residue
N°21 VDU overhead
FLUID RATES, KG/HR 1 H2O 2 H2S 4 H2 6 AIR 8 METHANE 9 ETHANE 10 ETHYLENE 11 PROPANE 12 PROPENE 13 IBUTANE 14 BUTANE 15 BUTENE-1 16 IPENTANE 17 PENTANE 18 NBP 38 19 NBP 45 20 NBP 55 21 NBP 65 22 NBP 75 23 NBP 85 24 NBP 95 25 NBP 105 26 NBP 115 27 NBP 125 28 NBP 135 29 NBP 145 30 NBP 155 31 NBP 165 32 NBP 175 33 NBP 185 34 NBP 195 35 NBP 205 36 NBP 215 37 NBP 225 38 NBP 235 39 NBP 245 40 NBP 255 41 NBP 265 42 NBP 275 43 NBP 285 44 NBP 295 45 NBP 305 46 NBP 315 47 NBP 325 48 NBP 335 49 NBP 345 50 NBP 355 51 NBP 365 52 NBP 375 53 NBP 385 54 NBP 395 55 NBP 405 56 NBP 415 57 NBP 425 58 NBP 435 59 NBP 445 60 NBP 455 61 NBP 470 62 NBP 490 63 NBP 510 64 NBP 530 65 NBP 550 66 NBP 570 67 NBP 590 68 NBP 610 69 NBP 630 70 NBP 660 71 NBP 700 72 NBP 740 73 NBP 780 74 NBP 820 75 NBP 860 76 NBP 900 77 NBP 940 78 NBP 980
0.7443 7.3343E-10 1.2460E-16 5.5816 3.9212E-11 7.5737E-11 1.1058E-11 9.1119E-10 1.6395E-10 6.3510E-10 4.6748E-09 1.4415E-09 7.2209E-09 1.2626E-08 1.5888E-13 7.0253E-13 1.6647E-12 4.1077E-12 1.0287E-11 2.5211E-11 5.6903E-11 1.2940E-10 2.8562E-07 5.8792E-07 1.0544E-06 1.6478E-06 2.7172E-06 4.1495E-06 6.1493E-06 7.6021E-06 9.7492E-06 1.3272E-05 1.7801E-05 2.2736E-05 3.0337E-05 4.4061E-05 6.1252E-05 9.0236E-05 1.5547E-04 3.2271E-04 7.2391E-04 1.6830E-03 4.0404E-03 9.4862E-03 0.0218 0.0488 0.1077 0.2318 0.4897 1.0121 2.0177 3.8432 7.0478 12.7258 22.8561 41.2803 74.3440 360.3401 1200.6980 3443.3681 7435.7463 20061.4560 12708.4984 15709.0033 16892.7978 16390.4600 30563.0895 28193.1450 26538.0282 25348.1174 24041.8611 23463.6720 23463.6720 23463.6720 14767.7512
12650.7763 0.0000 0.0000 0.0000 0.0000 348.9320 0.0000 5294.3761 0.0000 2345.5090 10352.5390 0.0000 6912.3876 12500.0086 1699.3835 4385.3596 4844.4757 5621.2491 6662.2071 7766.0382 8636.8906 9363.9258 9857.7332 10013.1130 9486.6333 7317.3725 3119.1400 600.3209 76.0278 8.1992 0.8300 0.0822 7.3760E-03 6.5135E-04 5.4981E-05 4.4393E-06 3.4088E-07 2.4823E-08 1.7036E-09 1.1100E-10 7.0083E-12 4.2011E-13 2.3831E-14 1.2806E-15 6.6548E-17 3.1780E-18 1.4476E-19 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000
9920.3523 0.0000 0.0000 0.0000 0.0000 343.3956 0.0000 5110.2554 0.0000 2197.4690 9575.3113 0.0000 5977.5067 10553.7832 1415.4516 3540.9811 3711.7631 4042.9214 4440.6939 4727.3548 4723.0207 4511.9084 4105.5920 3535.3469 2785.7684 1754.9155 602.0755 91.5327 9.0071 0.7425 0.0570 4.2759E-03 2.8321E-04 1.8443E-05 1.1379E-06 6.6726E-08 3.6948E-09 1.9255E-10 9.3816E-12 4.3093E-13 1.9150E-14 8.0293E-16 3.1638E-17 1.1734E-18 4.2012E-20 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000
1878.3249 0.0000 0.0000 0.0000 0.0000 0.8976 0.0000 89.7591 0.0000 141.3502 789.1010 0.0000 1264.5225 2612.4634 400.5935 1223.1889 1689.2019 2395.7837 3401.3186 4659.4752 5890.2294 7304.1766 8736.4405 10155.7456 11553.9116 13056.4645 14586.6645 15333.0573 15521.7153 15529.9800 15518.8729 15601.4732 15766.5722 16014.2149 16356.1975 16686.3874 16981.1999 17252.4274 17452.8999 17653.3724 17830.2599 17971.7699 18089.6949 18172.2424 18231.2049 18207.6199 18066.1099 17771.2974 17346.7674 16875.0674 16426.9524 16037.7999 15672.2324 15377.4199 15106.1925 14952.8900 14799.5875 29622.7599 32181.7324 34186.4574 33136.9249 49799.7273 21250.0849 20613.2899 19711.4475 18406.6661 33992.6684 31335.1265 29495.1512 28172.6431 26720.8313 26078.2150 26078.2150 26078.2150 26078.2150
25732.4824 0.0000 0.0000 0.0000 0.0000 2.0773 0.0000 502.7912 0.0000 556.6891 2481.7720 0.0000 3417.9614 6700.8838 2025.0642 3518.5017 4629.1587 6338.5322 8789.6455 11856.7686 14868.4463 18157.3789 20916.4238 22135.3570 20398.3842 15236.5742 7262.1870 1828.6754 308.7279 43.9061 5.8902 0.7792 0.0923 0.0104 1.0793E-03 8.9226E-05 5.0036E-06 1.6911E-07 3.8110E-09 6.7457E-11 1.0253E-12 1.2900E-14 1.2128E-16 7.1838E-19 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000
292.0201 0.0000 0.0000 0.0000 0.0000 2.0769E-08 0.0000 5.6409E-06 0.0000 3.0153E-05 1.9260E-04 0.0000 1.0875E-03 2.7045E-03 5.3609E-04 2.1555E-03 4.4002E-03 9.2115E-03 0.0193 0.0389 0.0712 0.1295 0.2262 0.3836 0.6350 1.0396 1.6845 2.5419 3.6963 5.4332 8.1798 12.7481 19.6856 31.3277 50.5553 82.2433 133.8187 217.1339 348.2904 552.2593 866.8709 1326.3447 1969.3191 2826.6491 3933.5821 5254.2746 6840.6023 8603.5083 10501.3102 12409.4099 14004.9559 14964.2784 15270.8072 15243.4183 15064.8290 14940.9183 14796.4461 29622.5346 32182.5345 34187.3880 33137.8316 49801.0903 21250.6666 20613.8541 19711.9870 18407.1699 33993.5988 31335.9842 29495.9584 28173.4142 26721.5627 26078.9288 26078.9288 26078.9288 26078.9288
25998.3367 140.1709 1.7569 43.8640 62.2292 58.3132 11.0389 81.1533 31.3344 19.5912 93.8587 35.4568 50.6322 79.9814 5.3596E-04 2.1546E-03 4.3969E-03 9.2008E-03 0.0192 0.0388 0.0710 0.1289 223.8057 357.1856 489.3237 575.0534 701.1771 776.5125 814.5956 690.2435 580.0008 486.0964 370.3470 245.0399 154.7314 98.5122 56.6524 33.1034 21.9192 17.0360 13.9710 11.5929 9.6858 7.6983 5.8157 4.1057 2.7008 1.5288 0.5654 0.0878 6.9326E-03 4.0934E-04 2.0594E-05 9.2437E-07 3.7582E-08 1.4036E-09 4.7963E-11 5.2504E-13 4.1349E-16 2.2994E-19 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000
TOTAL RATE, KG/HR
314217.7460
139863.5182
87677.2105
1.1034E+06
197715.2115
673532.9956
33457.0873
205.0000 10.2000 28.3029 856.5277 0.0000 1.0000 1.0000 0.0000
137.4395 3.7000 26.8186 63.2313 1.0000 0.0000 0.0000 0.0000
109.6037 3.0000 16.7888 55.6700 1.0000 0.0000 0.0000 0.0000
187.1777 3.9000 101.7310 288.4930 0.0000 1.0000 1.0000 0.0000
117.9696 1.0000 40.6263 62.9559 0.9999 1.4789E-04 1.4789E-04 0.0000
354.0567 14.9000 127.5268 555.5425 0.0000 1.0000 1.0000 0.0000
79.9999 -0.8999 17.3051 22.1507 1.0000 2.0482E-09 2.0482E-09 0.0000
TEMPERATURE, C PRESSURE, BAR(GA) ENTHALPY, M*KCAL/HR MOLECULAR WEIGHT WEIGHT FRAC VAPOR WEIGHT FRAC TOTAL LIQUID WEIGHT FRAC H/C LIQUID WEIGHT FRAC FREE WATER
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM ID NAME
REV: 03 Date: 12-MAY-11
N°22 Recovered Oil
N°23 Off-gas
FLUID RATES, KG/HR 1 H2O 2 H2S 4 H2 6 AIR 8 METHANE 9 ETHANE 10 ETHYLENE 11 PROPANE 12 PROPENE 13 IBUTANE 14 BUTANE 15 BUTENE-1 16 IPENTANE 17 PENTANE 18 NBP 38 19 NBP 45 20 NBP 55 21 NBP 65 22 NBP 75 23 NBP 85 24 NBP 95 25 NBP 105 26 NBP 115 27 NBP 125 28 NBP 135 29 NBP 145 30 NBP 155 31 NBP 165 32 NBP 175 33 NBP 185 34 NBP 195 35 NBP 205 36 NBP 215 37 NBP 225 38 NBP 235 39 NBP 245 40 NBP 255 41 NBP 265 42 NBP 275 43 NBP 285 44 NBP 295 45 NBP 305 46 NBP 315 47 NBP 325 48 NBP 335 49 NBP 345 50 NBP 355 51 NBP 365 52 NBP 375 53 NBP 385 54 NBP 395 55 NBP 405 56 NBP 415 57 NBP 425 58 NBP 435 59 NBP 445 60 NBP 455 61 NBP 470 62 NBP 490 63 NBP 510 64 NBP 530 65 NBP 550 66 NBP 570 67 NBP 590 68 NBP 610 69 NBP 630 70 NBP 660 71 NBP 700 72 NBP 740 73 NBP 780 74 NBP 820 75 NBP 860 76 NBP 900 77 NBP 940 78 NBP 980
1.5906 3.2329 4.3241E-04 0.0894 0.1321 0.5579 0.0738 2.5173 0.8497 1.3906 8.9663 2.9147 10.2276 20.4038 1.6456E-04 7.6795E-04 1.9228E-03 4.8670E-03 0.0121 0.0282 0.0580 0.1147 210.8057 347.5224 483.7560 572.2821 699.3830 775.0322 813.1689 689.0557 579.0057 485.2627 369.7119 244.6197 154.4661 98.3433 56.5552 33.0466 21.8816 17.0068 13.9471 11.5730 9.6692 7.6851 5.8057 4.0986 2.6962 1.5262 0.5645 0.0877 6.9207E-03 4.0863E-04 2.0559E-05 9.2279E-07 3.7518E-08 1.4012E-09 4.7881E-11 5.2414E-13 4.1278E-16 2.2955E-19 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000
49.2231 181.0071 2.3079 57.5555 81.6531 76.1597 14.4459 104.5458 40.4631 24.6210 115.9977 44.2645 58.1555 88.0040 5.5702E-04 2.1441E-03 4.0405E-03 7.5970E-03 0.0138 0.0229 0.0323 0.0417 46.4067 42.0416 28.4867 14.2741 6.3648 2.2091 0.6237 0.1226 0.0207 3.0693E-03 3.6671E-04 3.4293E-05 2.7954E-06 2.1212E-07 1.3529E-08 8.2029E-10 5.2913E-11 3.7697E-12 2.6698E-13 1.8039E-14 1.1577E-15 6.6687E-17 3.4457E-18 1.5702E-19 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000
25.2500 0.1247 1.7300 43.5400 61.8200 57.2300 10.9000 76.7500 29.7100 17.3200 79.3300 30.7100 35.1700 49.7500 3.1200E-04 0.0550 18.5598 15.8252 13.8799 11.5863 9.3141 7.5396 5.5047 2.9525 1.2628 0.3955 0.1107 0.0237 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000
98.6608 3.0965 4.1639E-04 0.0863 0.1275 0.5348 0.0708 2.4081 0.8129 1.3286 8.5639 2.7835 9.7681 19.4914 5.5598E-03 0.0229 0.0483 0.1042 0.2234 0.4604 0.8650 1.5927 204.2736 337.6175 472.9388 566.5933 705.1325 804.6480 884.3879 820.4739 797.4623 832.2661 881.0074 944.3058 1091.7974 1354.4353 1696.1878 2195.0995 2930.0032 4016.7210 5577.0605 7843.5910 11029.4104 14296.7172 16058.5498 16260.5703 15555.7907 13826.0093 10027.4816 5274.8190 2457.5074 1038.4990 383.7226 127.9324 39.7248 11.7699 3.3712 0.9849 0.0748 4.8861E-03 2.6365E-04 2.0425E-05 4.1319E-07 1.7497E-08 6.8495E-10 2.4748E-11 3.1854E-13 3.6816E-16 4.6946E-19 0 0 0 0 0 0
5.1170 0.1606 2.1596E-05 4.4768E-03 6.6110E-03 0.0277 3.6712E-03 0.1249 0.0422 0.0689 0.4442 0.1444 0.5066 1.0109 2.8836E-04 1.1885E-03 2.5058E-03 5.4032E-03 0.0116 0.0239 0.0449 0.0826 10.5946 17.5105 24.5289 29.3863 36.5716 41.7330 45.8687 42.5538 41.3603 43.1654 45.6933 48.9763 56.6259 70.2476 87.9725 113.8485 151.9642 208.3267 289.2535 406.8068 572.0388 741.4972 832.8744 843.3522 806.7989 717.0840 520.0739 273.5778 127.4583 53.8616 19.9017 6.6352 2.0603 0.6104 0.1748 0.0511 3.8791E-03 2.5342E-04 1.3674E-05 1.0593E-06 2.1430E-08 9.0748E-10 3.5525E-11 1.2835E-12 1.6521E-14 1.9095E-17 2.4349E-20 0 0 0 0 0 0
TOTAL RATE, KG/HR
6761.7341
1079.0823
606.3449
141500.000
7338.000
50.0000 7.5000 0.1520 140.2834 0.0000 1.0000 1.0000 0.0000
50.0000 0.3000 0.1388 37.0893 0.9991 8.9011E-04 6.2382E-04 2.6629E-04
65.0000 1.8000 0.0771 36.2949 1.0000 0.0000 0.0000 0.0000
50.0000 7.5000 2.5442 256.1411 0.0000 1.0000 1.0000 0.0000
50.0000 7.0000 0.1320 256.1411 0.0000 1.0000 1.0000 0.0000
TEMPERATURE, C PRESSURE, BAR(GA) ENTHALPY, M*KCAL/HR MOLECULAR WEIGHT WEIGHT FRAC VAPOR WEIGHT FRAC TOTAL LIQUID WEIGHT FRAC H/C LIQUID WEIGHT FRAC FREE WATER
N°24 Washed off-gas
N°25 HAGO+LVGO TO HP HDS
TR Project No.: 02020 Page 10 of 193
N°26 HAGO+LVGO TO STORAGE
Note 1 : Depending on cracked gasoil in vacuum heater, recovered oil can vary from 0.3 to 6.7 t/h
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
3.1.2.
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 11 of 193
PHYSICAL PROPERTIES – BASE CASE. FEED HEAT AND MATERIAL BALANCE
STREAM ID NAME
N°1 Crude
N°2 Wild naphtha
N°3 Total naphtha
N°4 Kerosene to LP HDS
N°5 Kerosene to storage
N°6 LAGO to LP HDS
N°7 LAGO to storage
4744.613 1179.250 40.000 2.000 248.545 19.469 16.510 1.00000 0.00000
88.929 8500 70.000 5.000 95.582 0.310 36.485 1.00000 0.00000
1767.514 152125 43.000 7.000 86.067 3.370 22.154 1.00000 0.00000
788.398 120112 70.000 7.000 152.350 2.204 18.353 1.00000 0.00000
87.600 13346 43.000 7.000 152.350 0.245 18.353 1.00000 0.00000
532.298 108303 50.000 7.000 203.463 2.111 19.488 1.00000 0.00898
59.144 12034 50.000 7.000 203.463 0.235 19.488 1.00000 0.00898
----- TOTAL VAPOR -----RATE, KG-MOL/HR K*KG/HR K*M3/HR NORM VAP RATE(1), K*M3/HR MOLECULAR WEIGHT ENTHALPY, KCAL/KG CP, KCAL/KG-C DENSITY, KG/K*M3 Z (FROM DENSITY) THERMAL COND, KCAL/HR-M-C VISCOSITY, CP
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
----- TOTAL LIQUID ----RATE, KG-MOL/HR K*KG/HR M3/HR GAL/MIN STD LIQ RATE, M3/HR MOLECULAR WEIGHT ENTHALPY, KCAL/KG CP, KCAL/KG-C DENSITY, KG/M3 Z (FROM DENSITY) SURFACE TENSION, DYNE/CM TH COND, KCAL/HR-M-C VISCOSITY, CP
4744.613 1179250 1356.400 5972.040 1330.393 248.545 16.510 0.452 869.397 0.0111 27.8002 0.08473 30.65
88.929 8500 13.068 57.535 12.180 95.582 36.485 0.564 650.466 0.0310 15.2635 0.09803 0.66715
1767.514 152125 233.922 1029.927 225.566 86.067 22.154 0.549 650.324 0.0403 16.2698 0.10524 1.84059
788.398 120112 156.781 690.287 153.263 152.350 18.353 0.495 766.113 0.0606 24.8997 0.10084 1.29335
87.600 13346 17.420 76.699 17.029 152.350 18.353 0.495 766.113 0.0606 24.8997 0.10084 1.29335
532.298 108303 133.619 588.305 130.318 203.463 19.488 0.482 810.537 0.0749 28.0857 0.09525 2.10806
59.144 12034 14.847 65.367 14.480 203.463 19.488 0.482 810.537 0.0749 28.0857 0.09525 2.10806
----- TOTAL STREAM ----RATE, KG-MOL/HR K*KG/HR TEMPERATURE, C PRESSURE, BAR(GA) MOLECULAR WEIGHT ENTHALPY, M*KCAL/HR KCAL/KG MOLE FRACTION LIQUID MOLE FRACTION FREE WATER
(1)
NORMAL VAPOR VOLUME IS 22.414 M3/KG-MOLE (0 C AND 1 ATM)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM ID NAME
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 12 of 193
N°8 HAGO to HP HDS
N°9 HAGO to storage
N°10 LVGO to HP HDS
N°11 LVGO to storage
N°12 HVGO to DHC/MHC
N°13 HVGO to storage
N°14 Vac Res to storage
376.511 97989 50.000 7.500 260.256 1.723 17.580 1.00000 0.00882
41.835 10888 50.000 7.500 260.256 0.191 17.580 1.00000 0.00882
112.304 29900 50.000 7.500 266.242 0.522 17.461 1.00000 0.00000
12.395 3300 50.000 7.500 266.242 5.762E-02 17.461 1.00000 0.00000
602.967 255165 160.000 11.500 423.182 17.969 70.420 1.00000 0.00000
66.996 28352 90.000 7.000 423.182 0.962 33.922 1.00000 0.00000
40.761 34913 180.000 7.000 856.528 2.665 76.340 1.00000 0.00000
----- TOTAL VAPOR -----RATE, KG-MOL/HR K*KG/HR K*M3/HR NORM VAP RATE(1), K*M3/HR MOLECULAR WEIGHT ENTHALPY, KCAL/KG CP, KCAL/KG-C DENSITY, KG/K*M3 Z (FROM DENSITY) THERMAL COND, KCAL/HR-M-C VISCOSITY, CP
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
----- TOTAL LIQUID ----RATE, KG-MOL/HR K*KG/HR M3/HR GAL/MIN STD LIQ RATE, M3/HR MOLECULAR WEIGHT ENTHALPY, KCAL/KG CP, KCAL/KG-C DENSITY, KG/M3 Z (FROM DENSITY) SURFACE TENSION, DYNE/CM TH COND, KCAL/HR-M-C VISCOSITY, CP
376.511 97989 114.653 504.802 112.073 260.256 17.580 0.462 854.659 0.0908 30.7544 0.09109 5.36514
41.835 10888 12.739 56.089 12.453 260.256 17.580 0.462 854.659 0.0908 30.7544 0.09109 5.36514
112.304 29900 34.867 153.515 34.084 266.242 17.461 0.460 857.543 0.0926 30.4312 0.09074 5.77634
12.395 3300 3.848 16.943 3.762 266.242 17.461 0.460 857.543 0.0926 30.4312 0.09074 5.77634
602.967 255165 296.814 1306.833 272.466 423.182 70.420 0.555 859.678 0.1642 26.1746 0.07419 2.31982
66.996 28352 31.645 139.328 30.274 423.182 33.922 0.483 895.931 0.1254 30.9153 0.07966 12.71535
40.761 34913 35.975 158.392 33.167 856.528 76.340 0.536 970.489 0.1877 31.4270 0.06483 17.92160
----- TOTAL STREAM ----RATE, KG-MOL/HR K*KG/HR TEMPERATURE, C PRESSURE, BAR(GA) MOLECULAR WEIGHT ENTHALPY, M*KCAL/HR KCAL/KG MOLE FRACTION LIQUID MOLE FRACTION FREE WATER
(1) NORMAL VAPOR VOLUME IS 22.414 M3/KG-MOLE (0 C AND 1 ATM)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM ID NAME
REV: 03 Date: 12-MAY-11
N°15 Vac Res to DCU
N°16 N°17 Preflash Naphtha from overhead preflash
366.851 314218 205.000 10.200 856.528 28.303 90.074 1.00000 0.00000
2211.935 139864 137.439 3.700 63.231 26.819 191.748 0.00000 0.00000
----- TOTAL VAPOR -----RATE, KG-MOL/HR K*KG/HR K*M3/HR NORM VAP RATE(1), K*M3/HR MOLECULAR WEIGHT ENTHALPY, KCAL/KG CP, KCAL/KG-C DENSITY, KG/K*M3 Z (FROM DENSITY) THERMAL COND, KCAL/HR-M-C VISCOSITY, CP
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
----- TOTAL LIQUID ----RATE, KG-MOL/HR K*KG/HR M3/HR GAL/MIN STD LIQ RATE, M3/HR MOLECULAR WEIGHT ENTHALPY, KCAL/KG CP, KCAL/KG-C DENSITY, KG/M3 Z (FROM DENSITY) SURFACE TENSION, DYNE/CM TH COND, KCAL/HR-M-C VISCOSITY, CP
366.851 314218 327.433 1441.644 298.506 856.528 90.074 0.559 959.639 0.2248 30.0331 0.06365 10.00801
----- TOTAL STREAM ----RATE, KG-MOL/HR K*KG/HR TEMPERATURE, C PRESSURE, BAR(GA) MOLECULAR WEIGHT ENTHALPY, M*KCAL/HR KCAL/KG MOLE FRACTION LIQUID MOLE FRACTION FREE WATER
TR Project No.: 02020 Page 13 of 193
N°18 CDU feed
N°19 CDU overhead
N°20 Atmospheric residue
N°21 VDU overhead
1574.946 87677 109.604 3.000 55.670 16.789 191.484 0.00000 0.00000
3824.604 1103371 187.178 3.900 288.493 101.731 92.200 1.00000 0.00000
3140.988 197715 117.970 1.000 62.947 39.967 202.143 8.18762E-05 0.00000
1212.388 673533 354.057 14.900 555.542 127.527 189.340 1.00000 0.00000
1510.428 33457 80.000 -0.900 22.151 17.305 517.234 1.76789E-10 0.00000
2211.935 139.864 15.170 49.578 63.231 191.748 0.512 9219.624 0.9469 0.02220 0.01008
1574.946 87.677 11.939 35.301 55.670 191.484 0.491 7343.981 0.9559 0.02017 0.00972
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
3140.988 197.715 49.411 70.402 62.947 202.143 0.478 4001.455 0.9739 0.01932 0.00939
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
1510.428 33.457 390.585 33.855 22.151 517.234 0.446 85.659 0.9980 0.01966 0.01090
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
3824.604 1103371 1377.421 6064.595 1211.659 288.493 92.200 0.587 801.041 0.1648 19.3039 0.06871 1.02592
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
1212.388 673533 827.830 3644.821 677.968 555.542 189.340 0.688 813.613 0.2044 16.5537 0.05542 0.70777
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
(1) NORMAL VAPOR VOLUME IS 22.414 M3/KG-MOLE (0 C AND 1 ATM)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM ID NAME
REV: 03 Date: 12-MAY-11
N°22 Recovered Oil
N°23 Off-gas
48.201 6762 50.000 7.500 140.283 0.152 22.486 1.00000 0.00000
29.094 1079 50.000 0.300 37.089 0.139 128.591 7.52757E-04 5.48236E-04
16.706 606 65.000 1.800 36.295 7.713E-02 127.200 0.00000 0.00000
562.093 141500 50.000 7.500 251.738 2.544 17.980 1.00000 0.00000
29.153 7338 50.000 7.000 251.738 0.132 17.980 1.00000 0.00000
----- TOTAL VAPOR -----RATE, KG-MOL/HR K*KG/HR K*M3/HR NORM VAP RATE(1), K*M3/HR MOLECULAR WEIGHT ENTHALPY, KCAL/KG CP, KCAL/KG-C DENSITY, KG/K*M3 Z (FROM DENSITY) THERMAL COND, KCAL/HR-M-C VISCOSITY, CP
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
29.094 1.079 0.595 0.652 37.084 128.677 0.400 1813.242 0.9996 0.02217 0.01050
16.706 0.606 0.231 0.374 36.295 127.200 0.448 2628.966 0.9886 0.02473 0.01084
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
----- TOTAL LIQUID ----RATE, KG-MOL/HR K*KG/HR M3/HR GAL/MIN STD LIQ RATE, M3/HR MOLECULAR WEIGHT ENTHALPY, KCAL/KG CP, KCAL/KG-C DENSITY, KG/M3 Z (FROM DENSITY) SURFACE TENSION, DYNE/CM TH COND, KCAL/HR-M-C VISCOSITY, CP
48.201 6762 9.046 39.830 8.775 140.283 22.486 0.509 747.459 0.0560 23.2620 0.10059 1.08098
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
562.093 141500 166.518 733.161 170.348 251.738 17.980 0.476 849.760 0.0900 30.2144 0.09000 4.91614
29.153 7338 8.636 38.025 8.835 251.738 17.980 0.476 849.760 0.0900 30.2144 0.09000 4.91614
----- TOTAL STREAM ----RATE, KG-MOL/HR K*KG/HR TEMPERATURE, C PRESSURE, BAR(GA) MOLECULAR WEIGHT ENTHALPY, M*KCAL/HR KCAL/KG MOLE FRACTION LIQUID MOLE FRACTION FREE WATER
N°24 Washed off-gas
N°25 HAGO+LVGO TO HP HDS
TR Project No.: 02020 Page 14 of 193
N°26 HAGO+LVGO TO STORAGE
(1) NORMAL VAPOR VOLUME IS 22.414 M3/KG-MOLE (0 C AND 1 ATM)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
3.2.
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 15 of 193
BASE CASE. EPCC HEAT AND MATERIAL BALANCE
Composition and physical properties for the additional streams, as well as for the main streams, are presented in this section. It should be noted that the information shown in this section has been obtained with a different software from the one used in the previous section, for that reason the results do not exactly correspond with the information presented in other proyect project documents (PFDs, data sheets, etc for instance). However, the differences are minimal and they do not affect the design of the equipments. Exception is viscosity for crude and vacuum residue, for which the results of the simulation differs from the data given in the heat and material balance of section 3.1. CASE. FEED HEAT AND MATERIAL BALANCE, being these later the ones to be used for design (refer to Technical Query JER-02020-TQR-DIST-DISRS-2009-000002). Wild Naphtha composition shown in this summary corresponds with the one coming from LP HDS and HP HDS, as defined in document Basis of Design, SA-JER-DS011-TRJR-320001, appendix 5.
3.2.1.
STREAMS COMPOSITIONS – BASE CASE. EPCC HEAT AND MATERIAL BALANCE
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 16 of 193
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
1
DESCRIPTION
CRUDE
Component
REV: 03 Date: 12-MAY-11 Rev.
2 WILD NAPHTHA
Rev.
3 TOTAL NAPHTHA
Rev.
TR Project No.: 02020 Page 17 of 193 4 KEROSENE TO LP HDS
Rev.
5
Rev.
KEROSENE TO STORAGE
Mass Frac (%)
H2O
0,00
0,00
3,01E-02
0,00
0,00
H2S
0,00
0,450
1,69E-02
0,00
0,00
HYDROGEN
0,00
0,00
0,00
0,00
0,00
AIR
0,00
0,00
0,00
0,00
0,00
METHANE
0,00
4,00E-02
6,93E-04
0,00
0,00 0,00
ETHANE
2,92E-02
0,520
0,237
0,00
ETHYLENE
0,00
0,00
0,00
0,00
0,00
PROPANE
0,441
1,73
3,37
0,00
0,00
PROPENE
0,00
0,00
0,00
0,00
0,00
IBUTANE
0,198
1,31
1,55
0,00
0,00
BUTANE
0,879
2,81
6,71
0,00
0,00
1-BUTENE
0,00
0,00
0,00
0,00
0,00
IPENTANE
0,614
2,48
4,72
0,00
0,00
PENTANE
1,12
2,33
8,47
0,00
0,00
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
0,154
5,59
1,45
0,00
0,00
NBP45*
0,404
3,51
3,21
0,00
0,00
NBP55.*
0,458
3,67
3,63
0,00
0,00
NBP65*
0,546
4,06
4,31
0,00
0,00
NBP75*
0,665
4,72
5,24
2,61E-04
2,61E-04
NBP85*
0,796
5,59
6,27
1,51E-03
1,51E-03
NBP95*
0,900
6,71
7,10
8,10E-03
8,10E-03
NBP105*
1,00
7,95
7,90
4,22E-02
4,22E-02
NBP115*
1,09
9,14
8,48
0,195
0,195
NBP125*
1,16
9,77
8,60
0,710
0,710
NBP135*
1,22
7,59
7,89
1,86
1,86
NBP145*
1,26
5,16
6,31
3,85
3,85
NBP155*
1,29
3,87
3,25
7,52
7,52
NBP165*
1,31
3,15
1,02
10,1
10,1
NBP175*
1,32
2,69
0,212
10,9
10,9
NBP185*
1,32
2,00
2,25E-02
10,7
10,7
NBP195*
1,32
1,21
3,04E-03
10,2
10,2
NBP205*
1,32
0,949
3,98E-04
9,70
9,70
NBP215*
1,34
0,956
0,00
9,02
9,02
NBP225*
1,36
3,54E-02
0,00
8,06
8,06
NBP235*
1,39
0,00
0,00
6,85
6,85
NBP245*
1,42
0,00
0,00
5,15
5,15
NBP255*
1,44
0,00
0,00
3,18
3,18
NBP265*
1,46
0,00
0,00
1,40
1,40
NBP275*
1,48
0,00
0,00
0,437
0,437
NBP285*
1,50
0,00
0,00
7,68E-02
7,68E-02
NBP295*
1,51
0,00
0,00
1,34E-02
1,34E-02
NBP305*
1,52
0,00
0,00
2,05E-03
2,05E-03
NBP315*
1,53
0,00
0,00
2,63E-04
2,63E-04
NBP325*
1,54
0,00
0,00
0,00
0,00
NBP335*
1,55
0,00
0,00
0,00
0,00
NBP345*
1,54
0,00
0,00
0,00
0,00
NBP355*
1,53
0,00
0,00
0,00
0,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 18 of 193
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 19 of 193
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 20 of 193
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 21 of 193
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 22 of 193
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 23 of 193
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 24 of 193
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 25 of 193
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 26 of 193
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 27 of 193
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 28 of 193
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 29 of 193
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 30 of 193
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 31 of 193
STREAM Nº
1
DESCRIPTION
CRUDE
WILD NAPHTHA
TOTAL NAPHTHA
KEROSENE TO LP HDS
KEROSENE TO STORAGE
NBP365*
1,51
0,00
0,00
0,00
0,00
NBP375*
1,47
0,00
0,00
0,00
0,00
NBP385*
1,43
0,00
0,00
0,00
0,00
NBP395*
1,39
0,00
0,00
0,00
0,00
NBP405*
1,36
0,00
0,00
0,00
0,00
NBP415*
1,33
0,00
0,00
0,00
0,00
NBP425*
1,30
0,00
0,00
0,00
0,00
NBP435*
1,28
0,00
0,00
0,00
0,00
NBP445*
1,27
0,00
0,00
0,00
0,00
NBP455*
1,26
0,00
0,00
0,00
0,00
NBP470*
2,51
0,00
0,00
0,00
0,00
NBP490*
2,73
0,00
0,00
0,00
0,00
NBP510*
2,90
0,00
0,00
0,00
0,00
NBP530*
2,81
0,00
0,00
0,00
0,00
NBP550*
4,22
0,00
0,00
0,00
0,00
NBP570*
1,80
0,00
0,00
0,00
0,00
NBP590*
1,75
0,00
0,00
0,00
0,00
NBP610*
1,67
0,00
0,00
0,00
0,00
NBP630*
1,56
0,00
0,00
0,00
0,00
NBP660*
2,88
0,00
0,00
0,00
0,00
NBP700*
2,66
0,00
0,00
0,00
0,00
NBP740*
2,50
0,00
0,00
0,00
0,00
NBP780*
2,39
0,00
0,00
0,00
0,00
NBP820*
2,27
0,00
0,00
0,00
0,00
NBP860*
2,21
0,00
0,00
0,00
0,00
NBP900*
2,21
0,00
0,00
0,00
0,00
NBP940*
2,21
0,00
0,00
0,00
0,00
NBP980*
2,21
0,00
0,00
0,00
0,00
Component
Rev.
2
Rev.
3
Rev.
4
Rev.
5
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 32 of 193
STREAM Nº
6
DESCRIPTION
LAGO TO LP HDS
LAGO TO STORAGE
HAGO TO HP HDS/ STORAGE
LVGO TO HP HDS/ STORAGE
HVGO TO DHC/MHC
2,51E-03
Component
Rev.
7
Rev.
8+9
Rev.
10+11
Rev.
12
Rev.
Mass Frac (%)
H2O
9,58E-02
9,58E-02
7,62E-02
5,84E-03
H2S
0,00
0,00
0,00
0,00
0,00
HYDROGEN
0,00
0,00
0,00
0,00
0,00
AIR
0,00
0,00
0,00
0,00
0,00
METHANE
0,00
0,00
0,00
0,00
0,00
ETHANE
0,00
0,00
0,00
0,00
0,00
ETHYLENE
0,00
0,00
0,00
0,00
0,00
PROPANE
0,00
0,00
0,00
0,00
0,00
PROPENE
0,00
0,00
0,00
0,00
0,00
IBUTANE
0,00
0,00
0,00
0,00
0,00
BUTANE
0,00
0,00
0,00
0,00
0,00
1-BUTENE
0,00
0,00
0,00
0,00
0,00
IPENTANE
0,00
0,00
0,00
0,00
0,00
PENTANE
2,12E-04
2,12E-04
0,00
1,73E-04
0,00
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
0,00
0,00
0,00
0,00
0,00 0,00
NBP45*
1,70E-04
1,70E-04
0,00
0,00
NBP55.*
3,58E-04
3,58E-04
0,00
0,00
0,00
NBP65*
7,74E-04
7,74E-04
1,01E-04
0,00
0,00
NBP75*
1,66E-03
1,66E-03
2,06E-04
0,00
0,00
NBP85*
3,54E-03
3,54E-03
4,10E-04
0,00
0,00
NBP95*
7,11E-03
7,11E-03
7,71E-04
0,00
0,00
NBP105*
1,40E-02
1,40E-02
1,39E-03
0,00
0,00
NBP115*
2,68E-02
2,68E-02
2,39E-03
3,53E-03
1,99E-04
NBP125*
5,03E-02
5,03E-02
4,00E-03
7,88E-03
3,64E-04
NBP135*
9,20E-02
9,20E-02
6,71E-03
1,54E-02
5,72E-04
NBP145*
0,165
0,165
1,15E-02
2,60E-02
7,75E-04
NBP155*
0,303
0,303
2,03E-02
4,99E-02
1,11E-03
NBP165*
0,478
0,478
3,25E-02
8,26E-02
1,43E-03
NBP175*
0,709
0,709
5,03E-02
0,132
1,80E-03
NBP185*
1,06
1,06
7,78E-02
0,197
1,88E-03
NBP195*
1,50
1,50
0,118
0,274
2,01E-03
NBP205*
2,10
2,10
0,180
0,390
2,28E-03
NBP215*
2,90
2,90
0,270
0,520
2,52E-03
NBP225*
3,97
3,97
0,402
0,621
2,63E-03
NBP235*
5,42
5,42
0,591
0,722
2,86E-03
NBP245*
7,31
7,31
0,852
0,853
3,35E-03
NBP255*
9,41
9,41
1,17
0,906
3,67E-03
NBP265*
11,2
11,2
1,60
0,970
4,23E-03
NBP275*
11,8
11,8
2,13
1,16
5,66E-03
NBP285*
11,4
11,4
3,06
1,62
9,55E-03
NBP295*
10,3
10,3
4,21
2,37
1,69E-02
NBP305*
8,60
8,60
5,79
3,49
3,07E-02
NBP315*
6,19
6,19
7,97
5,18
5,74E-02
NBP325*
3,36
3,36
10,4
7,35
0,105
NBP335*
1,21
1,21
11,8
9,98
0,187
NBP345*
0,310
0,310
11,7
12,7
0,327
NBP355*
6,41E-02
6,41E-02
10,5
15,3
0,585
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 33 of 193
STREAM Nº
6
DESCRIPTION
LAGO TO LP HDS
LAGO TO STORAGE
HAGO TO HP HDS/ STORAGE
LVGO TO HP HDS/ STORAGE
HVGO TO DHC/MHC
NBP365*
1,16E-02
1,16E-02
8,84
16,2
1,11
NBP375*
1,89E-03
1,89E-03
6,98
12,4
2,24
NBP385*
2,72E-04
2,72E-04
5,02
5,03
3,79
NBP395*
0,00
0,00
3,18
1,13
4,81
NBP405*
0,00
0,00
1,71
0,189
5,26
NBP415*
0,00
0,00
0,787
2,72E-02
5,39
NBP425*
0,00
0,00
0,319
3,55E-03
5,38
NBP435*
0,00
0,00
0,118
4,30E-04
5,32
NBP445*
0,00
0,00
4,09E-02
0,00
5,27
NBP455*
0,00
0,00
1,38E-02
0,00
5,22
NBP470*
0,00
0,00
5,23E-03
0,00
10,4
NBP490*
0,00
0,00
5,04E-04
0,00
11,2
NBP510*
0,00
0,00
0,00
0,00
11,3
NBP530*
0,00
0,00
0,00
0,00
8,84
NBP550*
0,00
0,00
0,00
0,00
9,52
NBP570*
0,00
0,00
0,00
0,00
2,32
NBP590*
0,00
0,00
0,00
0,00
0,939
NBP610*
0,00
0,00
0,00
0,00
0,269
NBP630*
0,00
0,00
0,00
0,00
5,89E-02
NBP660*
0,00
0,00
0,00
0,00
9,76E-03
NBP700*
0,00
0,00
0,00
0,00
2,99E-04
NBP740*
0,00
0,00
0,00
0,00
0,00
NBP780*
0,00
0,00
0,00
0,00
0,00
NBP820*
0,00
0,00
0,00
0,00
0,00
NBP860*
0,00
0,00
0,00
0,00
0,00
NBP900*
0,00
0,00
0,00
0,00
0,00
NBP940*
0,00
0,00
0,00
0,00
0,00
NBP980*
0,00
0,00
0,00
0,00
0,00
Component
Rev.
7
Rev.
8+9
Rev.
10+11
Rev.
12
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
13
DESCRIPTION
HVGO TO STORAGE
VAC.RESIDUE TO STORAGE
VAC. RESIDUE TO DCU
Component
Rev.
14
Rev.
15
Rev.
TR Project No.: 02020 Page 34 of 193 16 PREFLASH OVERHEAD
Rev.
17
Rev.
NAPHTHA FROM PREFLASH
Mass Frac (%)
H2O
2,51E-03
2,03E-03
2,03E-03
9,10
11,4
H2S
0,00
0,00
0,00
0,00
0,00
HYDROGEN
0,00
0,00
0,00
0,00
0,00
AIR
0,00
0,00
0,00
0,00
0,00
METHANE
0,00
0,00
0,00
0,00
0,00
ETHANE
0,00
0,00
0,00
0,243
0,387
ETHYLENE
0,00
0,00
0,00
0,00
0,00
PROPANE
0,00
0,00
0,00
3,65
5,70
PROPENE
0,00
0,00
0,00
0,00
0,00
IBUTANE
0,00
0,00
0,00
1,60
2,42
BUTANE
0,00
0,00
0,00
7,04
10,5
1-BUTENE
0,00
0,00
0,00
0,00
0,00
IPENTANE
0,00
0,00
0,00
4,69
6,56 11,6
PENTANE
0,00
0,00
0,00
8,51
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
0,00
0,00
0,00
1,16
1,56 3,93
NBP45*
0,00
0,00
0,00
3,01
NBP55.*
0,00
0,00
0,00
3,34
4,16
NBP65*
0,00
0,00
0,00
3,91
4,58
NBP75*
0,00
0,00
0,00
4,68
5,08
NBP85*
0,00
0,00
0,00
5,50
5,47
NBP95*
0,00
0,00
0,00
6,13
5,47
NBP105*
0,00
0,00
0,00
6,72
5,29
NBP115*
1,99E-04
0,00
0,00
7,17
4,88
NBP125*
3,64E-04
0,00
0,00
7,39
4,26
NBP135*
5,72E-04
0,00
0,00
7,19
3,45
NBP145*
7,75E-04
0,00
0,00
5,94
2,34
NBP155*
1,11E-03
0,00
0,00
2,45
0,745
NBP165*
1,43E-03
0,00
0,00
0,502
0,122
NBP175*
1,80E-03
0,00
0,00
7,13E-02
1,37E-02
NBP185*
1,88E-03
0,00
0,00
5,21E-03
7,22E-04
NBP195*
2,01E-03
0,00
0,00
5,15E-04
0,00
NBP205*
2,28E-03
0,00
0,00
0,00
0,00
NBP215*
2,52E-03
0,00
0,00
0,00
0,00
NBP225*
2,63E-03
0,00
0,00
0,00
0,00
NBP235*
2,86E-03
0,00
0,00
0,00
0,00
NBP245*
3,35E-03
0,00
0,00
0,00
0,00
NBP255*
3,67E-03
0,00
0,00
0,00
0,00
NBP265*
4,23E-03
0,00
0,00
0,00
0,00
NBP275*
5,66E-03
0,00
0,00
0,00
0,00
NBP285*
9,55E-03
0,00
0,00
0,00
0,00
NBP295*
1,69E-02
0,00
0,00
0,00
0,00
NBP305*
3,07E-02
0,00
0,00
0,00
0,00
NBP315*
5,74E-02
0,00
0,00
0,00
0,00
NBP325*
0,105
0,00
0,00
0,00
0,00
NBP335*
0,187
0,00
0,00
0,00
0,00
NBP345*
0,327
0,00
0,00
0,00
0,00
NBP355*
0,585
0,00
0,00
0,00
0,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 35 of 193
STREAM Nº
13
DESCRIPTION
HVGO TO STORAGE
VAC.RESIDUE TO STORAGE
VAC. RESIDUE TO DCU
PREFLASH OVERHEAD
NAPHTHA FROM PREFLASH
NBP365*
1,11
0,00
0,00
0,00
0,00
NBP375*
2,24
0,00
0,00
0,00
0,00
NBP385*
3,79
0,00
0,00
0,00
0,00
NBP395*
4,81
0,00
0,00
0,00
0,00
NBP405*
5,26
1,72E-04
1,72E-04
0,00
0,00
NBP415*
5,39
3,62E-04
3,62E-04
0,00
0,00
NBP425*
5,38
7,48E-04
7,48E-04
0,00
0,00
NBP435*
5,32
1,54E-03
1,54E-03
0,00
0,00
NBP445*
5,27
3,16E-03
3,16E-03
0,00
0,00
NBP455*
5,22
6,50E-03
6,50E-03
0,00
0,00
NBP470*
10,4
3,84E-02
3,84E-02
0,00
0,00
NBP490*
11,2
0,167
0,167
0,00
0,00
NBP510*
11,3
0,617
0,617
0,00
0,00
NBP530*
8,84
2,33
2,33
0,00
0,00
NBP550*
9,52
6,57
6,57
0,00
0,00
NBP570*
2,32
4,22
4,22
0,00
0,00
NBP590*
0,939
5,16
5,16
0,00
0,00
Component
Rev.
14
Rev.
15
Rev.
16
Rev.
17
Rev.
Mass Frac (%)
NBP610*
0,269
5,44
5,44
0,00
0,00
NBP630*
5,89E-02
5,24
5,24
0,00
0,00
NBP660*
9,76E-03
9,76
9,76
0,00
0,00
NBP700*
2,99E-04
9,00
9,00
0,00
0,00
NBP740*
0,00
8,47
8,47
0,00
0,00
NBP780*
0,00
8,09
8,09
0,00
0,00
NBP820*
0,00
7,68
7,68
0,00
0,00
NBP860*
0,00
7,49
7,49
0,00
0,00
NBP900*
0,00
7,49
7,49
0,00
0,00
NBP940*
0,00
7,49
7,49
0,00
0,00
NBP980*
0,00
4,72
4,72
0,00
0,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
18
DESCRIPTION
TOPPED CRUDE
Component
REV: 03 Date: 12-MAY-11 Rev.
19
Rev.
20
CDU OVERHEAD
ATM. RESIDUE
Rev.
TR Project No.: 02020 Page 36 of 193 21 VDU OVERHEAD
Rev.
22
Rev.
RECOVERED OIL
Mass Frac (%)
H2O
0,139
12,9
4,40E-02
75,0
2,38E-02
H2S
0,00
3,52E-02
0,00
0,404
2,48E-02
HYDROGEN
0,00
0,00
0,00
5,07E-03
0,00
AIR
0,00
0,00
0,00
0,126
8,72E-04
METHANE
0,00
2,35E-03
0,00
0,179
1,96E-03
ETHANE
2,73E-04
4,18E-02
0,00
0,168
7,50E-03
ETHYLENE
0,00
0,00
0,00
3,18E-02
1,08E-03
PROPANE
1,61E-02
0,324
0,00
0,234
3,18E-02
PROPENE
0,00
0,00
0,00
9,03E-02
1,07E-02
IBUTANE
1,84E-02
0,331
0,00
5,65E-02
1,82E-02
BUTANE
9,73E-02
1,40
0,00
0,271
0,115
1-BUTENE
0,00
0,00
0,00
0,102
3,86E-02
IPENTANE
0,133
1,82
0,00
0,146
0,136
PENTANE
0,264
3,38
0,00
0,231
0,263
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
3,97E-02
0,996
0,00
0,00
0,00
NBP45*
0,118
1,75
0,00
1,61E-04
2,38E-04
NBP55.*
0,157
2,24
0,00
5,34E-02
9,98E-02
NBP65*
0,218
3,02
0,00
4,55E-02
0,105
NBP75*
0,305
4,13
0,00
3,99E-02
0,110
NBP85*
0,414
5,54
0,00
3,33E-02
0,107
NBP95*
0,525
6,98
0,00
2,69E-02
9,73E-02
NBP105*
0,648
8,54
0,00
2,19E-02
8,62E-02
NBP115*
0,774
9,95
0,00
0,624
2,58
NBP125*
0,901
10,8
0,00
1,01
4,30
NBP135*
1,02
10,3
1,18E-04
1,40
6,03
NBP145*
1,16
8,65
1,88E-04
1,65
7,17
NBP155*
1,32
4,90
3,00E-04
2,02
8,79
NBP165*
1,39
1,65
4,40E-04
2,25
9,78
NBP175*
1,41
0,353
6,33E-04
2,39
10,4
NBP185*
1,41
3,83E-02
9,26E-04
2,04
8,88
NBP195*
1,41
5,22E-03
1,37E-03
1,77
7,68
NBP205*
1,41
6,86E-04
2,08E-03
1,56
6,78
NBP215*
1,43
0,00
3,23E-03
1,30
5,63
NBP225*
1,45
0,00
5,11E-03
0,972
4,22
NBP235*
1,48
0,00
8,22E-03
0,720
3,13
NBP245*
1,51
0,00
1,33E-02
0,551
2,40
NBP255*
1,54
0,00
2,03E-02
0,387
1,68
NBP265*
1,56
0,00
3,12E-02
0,275
1,20
NBP275*
1,58
0,00
4,69E-02
0,221
0,962
NBP285*
1,60
0,00
8,11E-02
0,203
0,884
NBP295*
1,62
0,00
0,128
0,200
0,871
NBP305*
1,63
0,00
0,197
0,200
0,871
NBP315*
1,64
0,00
0,293
0,203
0,883
NBP325*
1,65
0,00
0,421
0,197
0,857
NBP335*
1,65
0,00
0,581
0,184
0,799
NBP345*
1,65
0,00
0,771
0,161
0,700
NBP355*
1,64
0,00
0,985
0,132
0,576
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 37 of 193
STREAM Nº
18
DESCRIPTION
TOPPED CRUDE
CDU OVERHEAD
ATM. RESIDUE
VDU OVERHEAD
RECOVERED OIL
NBP365*
1,61
0,00
1,22
9,55E-02
0,415
NBP375*
1,57
0,00
1,46
4,96E-02
0,216
NBP385*
1,53
0,00
1,71
1,36E-02
5,92E-02
NBP395*
1,49
0,00
1,94
2,07E-03
8,98E-03
NBP405*
1,45
0,00
2,12
2,31E-04
1,00E-03
NBP415*
1,42
0,00
2,22
0,00
0,00
NBP425*
1,39
0,00
2,25
0,00
0,00
NBP435*
1,37
0,00
2,24
0,00
0,00
NBP445*
1,36
0,00
2,23
0,00
0,00
NBP455*
1,34
0,00
2,21
0,00
0,00
NBP470*
2,69
0,00
4,43
0,00
0,00
NBP490*
2,92
0,00
4,82
0,00
0,00
NBP510*
3,10
0,00
5,12
0,00
0,00
NBP530*
3,01
0,00
4,96
0,00
0,00
NBP550*
4,52
0,00
7,45
0,00
0,00
NBP570*
1,93
0,00
3,18
0,00
0,00
NBP590*
1,87
0,00
3,09
0,00
0,00
NBP610*
1,79
0,00
2,95
0,00
0,00
NBP630*
1,67
0,00
2,75
0,00
0,00
NBP660*
3,08
0,00
5,09
0,00
0,00
NBP700*
2,84
0,00
4,69
0,00
0,00
NBP740*
2,67
0,00
4,41
0,00
0,00
NBP780*
2,55
0,00
4,22
0,00
0,00
NBP820*
2,42
0,00
4,00
0,00
0,00
NBP860*
2,36
0,00
3,90
0,00
0,00
NBP900*
2,36
0,00
3,90
0,00
0,00
NBP940*
2,36
0,00
3,90
0,00
0,00
NBP980*
2,36
0,00
3,90
0,00
0,00
Component
Rev.
19
Rev.
20
Rev.
21
Rev.
22
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 23
STREAM Nº
OFF GAS
DESCRIPTION
Component
REV: 03 Date: 12-MAY-11 Rev.
24 WASHED OFF GAS
Rev.
25 HAGO+LVGO TO HP HDS
Rev.
TR Project No.: 02020 Page 38 of 193 36 DESALTED CRUDE TO 011-G-0002 A/B
Rev.
51
Rev.
HAGO PA TO 011-G-0012 A/B
Mass Frac (%)
H2O
4,48
4,26
5,78E-02
0,832
H2S
16,0
2,08E-02
1,33E-03
0,00
0,00
HYDROGEN
0,202
0,293
0,00
0,00
0,00
2,89E-02
AIR
5,03
7,32
0,00
0,00
0,00
METHANE
7,13
10,4
1,05E-04
0,00
0,00 0,00
ETHANE
6,65
9,64
4,02E-04
2,90E-02
ETHYLENE
1,26
1,83
0,00
0,00
0,00
PROPANE
9,15
13,1
1,70E-03
0,437
3,82E-04
PROPENE
3,54
5,08
5,71E-04
0,00
0,00
IBUTANE
2,16
3,03
9,71E-04
0,197
6,23E-04 3,46E-03
BUTANE
10,2
14,1
6,14E-03
0,872
1-BUTENE
3,87
5,40
2,06E-03
0,00
0,00
IPENTANE
5,09
6,64
7,27E-03
0,609
6,74E-03 1,39E-02
PENTANE
7,77
9,86
1,40E-02
1,11
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
0,00
2,30E-04
0,00
0,153
2,23E-03 7,14E-03
NBP45*
5,08E-03
0,00
0,00
0,401
NBP55.*
1,55
6,15E-03
5,36E-03
0,454
1,06E-02
NBP65*
1,18
1,77
5,68E-03
0,541
1,64E-02
NBP75*
0,891
1,24
6,04E-03
0,659
2,55E-02
NBP85*
0,607
0,843
6,02E-03
0,789
3,85E-02
NBP95*
0,373
0,504
5,75E-03
0,893
5,44E-02
NBP105*
0,214
0,263
5,61E-03
0,994
7,48E-02
NBP115*
3,89
0,124
0,140
1,08
9,92E-02
NBP125*
3,65
1,79
0,233
1,15
0,128
NBP135*
2,63
1,31
0,329
1,21
0,163
NBP145*
1,49
0,715
0,395
1,25
0,209
NBP155*
0,635
0,308
0,493
1,28
0,273
NBP165*
0,275
8,94E-02
0,562
1,30
0,329
NBP175*
0,106
2,83E-02
0,617
1,31
0,386
NBP185*
1,92E-02
0,00
0,572
1,31
0,452
NBP195*
4,48E-03
0,00
0,555
1,31
0,531
NBP205*
1,01E-03
0,00
0,577
1,31
0,633
NBP215*
2,07E-04
0,00
0,611
1,33
0,765
NBP225*
0,00
0,00
0,654
1,35
0,936
NBP235*
0,00
0,00
0,755
1,38
1,16
NBP245*
0,00
0,00
0,934
1,40
1,44
NBP255*
0,00
0,00
1,14
1,43
1,77
NBP265*
0,00
0,00
1,44
1,45
2,18
NBP275*
0,00
0,00
1,85
1,47
2,68
NBP285*
0,00
0,00
2,63
1,48
3,53
NBP295*
0,00
0,00
3,62
1,50
4,55
NBP305*
0,00
0,00
5,02
1,51
5,94
NBP315*
0,00
0,00
6,97
1,52
7,83
NBP325*
0,00
0,00
9,22
1,53
9,87
NBP335*
0,00
0,00
10,8
1,53
10,9
NBP345*
0,00
0,00
11,3
1,53
10,5
NBP355*
0,00
0,00
11,0
1,52
9,27
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
23
REV: 03 Date: 12-MAY-11 Rev.
24
Rev.
25
Rev.
TR Project No.: 02020 Page 39 of 193 36 DESALTED CRUDE TO
Rev.
51 HAGO PA TO 011-G-0012 A/B
OFF GAS
WASHED OFF GAS
HAGO+LVGO TO HP HDS
NBP365*
0,00
0,00
10,0
1,49
7,71
NBP375*
0,00
0,00
7,81
1,46
6,00
NBP385*
0,00
0,00
4,76
1,42
4,28
NBP395*
0,00
0,00
2,55
1,38
2,68
NBP405*
0,00
0,00
1,29
1,35
1,44
NBP415*
0,00
0,00
0,577
1,32
0,657
NBP425*
0,00
0,00
0,232
1,29
0,265
NBP435*
0,00
0,00
8,60E-02
1,27
9,81E-02
NBP445*
0,00
0,00
2,97E-02
1,26
3,38E-02
NBP455*
0,00
0,00
1,00E-02
1,24
1,14E-02
NBP470*
0,00
0,00
3,80E-03
2,49
4,30E-03
NBP490*
0,00
0,00
3,65E-04
2,71
4,13E-04
NBP510*
0,00
0,00
0,00
2,87
0,00
NBP530*
0,00
0,00
0,00
2,79
0,00
NBP550*
0,00
0,00
0,00
4,19
0,00
NBP570*
0,00
0,00
0,00
1,79
0,00
NBP590*
0,00
0,00
0,00
1,73
0,00
NBP610*
0,00
0,00
0,00
1,66
0,00
NBP630*
0,00
0,00
0,00
1,55
0,00
NBP660*
0,00
0,00
0,00
2,86
0,00
NBP700*
0,00
0,00
0,00
2,64
0,00
NBP740*
0,00
0,00
0,00
2,48
0,00
NBP780*
0,00
0,00
0,00
2,37
0,00
NBP820*
0,00
0,00
0,00
2,25
0,00
NBP860*
0,00
0,00
0,00
2,19
0,00
NBP900*
0,00
0,00
0,00
2,19
0,00
NBP940*
0,00
0,00
0,00
2,19
0,00
NBP980*
0,00
0,00
0,00
2,19
0,00
DESCRIPTION
Component
011-G-0002 A/B
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
53
REV: 03 Date: 12-MAY-11 Rev.
54
Rev.
59
Rev.
TR Project No.: 02020 Page 40 of 193 61
Rev.
62
HAGO TO 011-C-0006
HAGO TO 011-G-0013 A/B
LAGO PA TO 011-G-0010 A/B
H2O
2,89E-02
7,62E-02
4,51E-02
4,51E-02
H2S
0,00
0,00
0,00
0,00
0,00
HYDROGEN
0,00
0,00
0,00
0,00
0,00
DESCRIPTION
Component
LAGO TO 011-C-0005
LAGO TO 011-G-0011 A/B
9,58E-02
Rev.
Mass Frac (%)
AIR
0,00
0,00
0,00
0,00
0,00
METHANE
0,00
0,00
0,00
0,00
0,00
ETHANE
0,00
0,00
0,00
0,00
0,00
ETHYLENE
0,00
0,00
0,00
0,00
0,00
PROPANE
3,82E-04
0,00
5,92E-04
5,92E-04
0,00
PROPENE
0,00
0,00
0,00
0,00
0,00
IBUTANE
6,23E-04
0,00
1,03E-03
1,03E-03
0,00 0,00
BUTANE
3,46E-03
0,00
5,90E-03
5,90E-03
1-BUTENE
0,00
0,00
0,00
0,00
0,00
IPENTANE
6,74E-03
0,00
1,22E-02
1,22E-02
0,00
PENTANE
1,39E-02
0,00
2,57E-02
2,57E-02
2,12E-04
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
2,23E-03
0,00
4,14E-03
4,14E-03
0,00 1,70E-04
NBP45*
7,14E-03
0,00
1,35E-02
1,35E-02
NBP55.*
1,06E-02
0,00
2,04E-02
2,04E-02
3,58E-04
NBP65*
1,64E-02
1,01E-04
3,22E-02
3,22E-02
7,74E-04
NBP75*
2,55E-02
2,06E-04
5,10E-02
5,10E-02
1,66E-03
NBP85*
3,85E-02
4,10E-04
7,91E-02
7,91E-02
3,54E-03
NBP95*
5,44E-02
7,71E-04
0,116
0,116
7,11E-03
NBP105*
7,48E-02
1,39E-03
0,166
0,166
1,40E-02
NBP115*
9,92E-02
2,39E-03
0,232
0,232
2,68E-02
NBP125*
0,128
4,00E-03
0,320
0,320
5,03E-02
NBP135*
0,163
6,71E-03
0,437
0,437
9,20E-02
NBP145*
0,209
1,15E-02
0,597
0,597
0,165
NBP155*
0,273
2,03E-02
0,844
0,844
0,303
NBP165*
0,329
3,25E-02
1,09
1,09
0,478
NBP175*
0,386
5,03E-02
1,35
1,35
0,709
NBP185*
0,452
7,78E-02
1,71
1,71
1,06
NBP195*
0,531
0,118
2,14
2,14
1,50
NBP205*
0,633
0,180
2,70
2,70
2,10
NBP215*
0,765
0,270
3,43
3,43
2,90
NBP225*
0,936
0,402
4,40
4,40
3,97
NBP235*
1,16
0,591
5,67
5,67
5,42
NBP245*
1,44
0,852
7,33
7,33
7,31
NBP255*
1,77
1,17
9,13
9,13
9,41
NBP265*
2,18
1,60
10,5
10,5
11,2
NBP275*
2,68
2,13
10,9
10,9
11,8
NBP285*
3,53
3,06
10,3
10,3
11,4
NBP295*
4,55
4,21
9,14
9,14
10,3
NBP305*
5,94
5,79
7,55
7,55
8,60
NBP315*
7,83
7,97
5,39
5,39
6,19
NBP325*
9,87
10,4
2,89
2,89
3,36
NBP335*
10,9
11,8
1,04
1,04
1,21
NBP345*
10,5
11,7
0,264
0,264
0,310
NBP355*
9,27
10,5
5,44E-02
5,44E-02
6,41E-02
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
53
REV: 03 Date: 12-MAY-11
Rev.
54
Rev.
59
Rev.
TR Project No.: 02020 Page 41 of 193
61
Rev.
62
HAGO TO 011-C-0006
HAGO TO 011-G-0013 A/B
LAGO PA TO 011-G-0010 A/B
NBP365*
7,71
8,84
9,84E-03
9,84E-03
1,16E-02
NBP375*
6,00
6,98
1,60E-03
1,60E-03
1,89E-03
NBP385*
4,28
5,02
2,30E-04
2,30E-04
2,72E-04
NBP395*
2,68
3,18
0,00
0,00
0,00
NBP405*
1,44
1,71
0,00
0,00
0,00
NBP415*
0,657
0,787
0,00
0,00
0,00
NBP425*
0,265
0,319
0,00
0,00
0,00
NBP435*
9,81E-02
0,118
0,00
0,00
0,00
NBP445*
3,38E-02
4,09E-02
0,00
0,00
0,00
NBP455*
1,14E-02
1,38E-02
0,00
0,00
0,00
NBP470*
4,30E-03
5,23E-03
0,00
0,00
0,00
NBP490*
4,13E-04
5,04E-04
0,00
0,00
0,00
NBP510*
0,00
0,00
0,00
0,00
0,00
NBP530*
0,00
0,00
0,00
0,00
0,00
NBP550*
0,00
0,00
0,00
0,00
0,00
NBP570*
0,00
0,00
0,00
0,00
0,00
NBP590*
0,00
0,00
0,00
0,00
0,00
NBP610*
0,00
0,00
0,00
0,00
0,00
NBP630*
0,00
0,00
0,00
0,00
0,00
NBP660*
0,00
0,00
0,00
0,00
0,00
NBP700*
0,00
0,00
0,00
0,00
0,00
NBP740*
0,00
0,00
0,00
0,00
0,00
NBP780*
0,00
0,00
0,00
0,00
0,00
NBP820*
0,00
0,00
0,00
0,00
0,00
NBP860*
0,00
0,00
0,00
0,00
0,00
NBP900*
0,00
0,00
0,00
0,00
0,00
NBP940*
0,00
0,00
0,00
0,00
0,00
NBP980*
0,00
0,00
0,00
0,00
0,00
DESCRIPTION
Component
LAGO TO 011-C-0005
LAGO TO 011-G-0011 A/B
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
67 KERO PA TO
DESCRIPTION
Component
011-G-0008 A/B
REV: 03 Date: 12-MAY-11 Rev.
69 KERO TO 011-C-0005
Rev.
70 KERO TO 011-G-0009 A/B
Rev.
TR Project No.: 02020 Page 42 of 193 75
77 (1)
NAPHTHA TO 011-E-0021
ATM. RESIDUE TO 011-C-0003
Rev.
Mass Frac (%)
H2O
8,47E-02
8,47E-02
0,00
6,06
1,23
H2S
0,00
0,00
0,00
1,59E-02
2,06E-02
HYDROGEN
0,00
0,00
0,00
0,00
2,58E-04
AIR
0,00
0,00
0,00
0,00
6,44E-03
METHANE
0,00
0,00
0,00
6,52E-04
9,13E-03 8,56E-03
ETHANE
0,00
0,00
0,00
0,223
ETHYLENE
0,00
0,00
0,00
0,00
1,62E-03
PROPANE
1,34E-03
1,34E-03
0,00
3,17
1,19E-02
PROPENE
0,00
0,00
0,00
0,00
4,60E-03
IBUTANE
2,61E-03
2,61E-03
0,00
1,45
2,88E-03 1,38E-02
BUTANE
1,49E-02
1,49E-02
0,00
6,30
1-BUTENE
0,00
0,00
0,00
0,00
5,21E-03
IPENTANE
3,47E-02
3,47E-02
0,00
4,44
7,44E-03
PENTANE
7,47E-02
7,47E-02
0,00
7,96
1,18E-02
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
1,56E-02
1,56E-02
0,00
0,153
0,00
NBP45*
4,41E-02
4,41E-02
0,00
0,401
0,00
NBP55.*
7,16E-02
7,16E-02
0,00
0,454
2,72E-03
NBP65*
0,122
0,122
0,00
0,541
2,32E-03
NBP75*
0,211
0,211
2,61E-04
0,659
2,04E-03
NBP85*
0,361
0,361
1,51E-03
0,789
1,70E-03
NBP95*
0,582
0,582
8,10E-03
0,893
1,37E-03
NBP105*
0,927
0,927
4,22E-02
0,994
1,12E-03
NBP115*
1,45
1,45
0,195
1,08
3,20E-02
NBP125*
2,23
2,23
0,710
1,15
5,20E-02
NBP135*
3,37
3,37
1,86
1,21
7,22E-02
NBP145*
5,15
5,15
3,85
1,25
8,57E-02
NBP155*
8,41
8,41
7,52
1,28
0,106
NBP165*
10,3
10,3
10,1
1,30
0,119
NBP175*
10,5
10,5
10,9
1,31
0,129
NBP185*
9,83
9,83
10,7
1,31
0,114
NBP195*
9,11
9,11
10,2
1,31
0,104
NBP205*
8,43
8,43
9,70
1,31
9,93E-02
NBP215*
7,70
7,70
9,02
1,33
9,23E-02
NBP225*
6,80
6,80
8,06
1,35
8,08E-02
NBP235*
5,71
5,71
6,85
1,38
7,30E-02
NBP245*
4,27
4,27
5,15
1,40
7,10E-02
NBP255*
2,62
2,62
3,18
1,43
6,53E-02
NBP265*
1,15
1,15
1,40
1,45
6,30E-02
NBP275*
0,357
0,357
0,437
1,47
7,03E-02
NBP285*
6,25E-02
6,25E-02
7,68E-02
1,48
9,34E-02
NBP295*
1,09E-02
1,09E-02
1,34E-02
1,50
0,133
NBP305*
1,67E-03
1,67E-03
2,05E-03
1,51
0,193
NBP315*
2,13E-04
2,13E-04
2,63E-04
1,52
0,287
NBP325*
0,00
0,00
0,00
1,53
0,411
NBP335*
0,00
0,00
0,00
1,53
0,573
NBP345*
0,00
0,00
0,00
1,53
0,765
NBP355*
0,00
0,00
0,00
1,52
0,997
NOTES: (1) Cracking in the vacuum heater has been considered.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
67 KERO PA TO
DESCRIPTION
Component
011-G-0008 A/B
REV: 03 Date: 12-MAY-11
Rev.
69
Rev.
KERO TO 011-C-0005
70
75
77 (1)
011-G-0009 A/B
NAPHTHA TO 011-E-0021
ATM. RESIDUE TO 011-C-0003
KERO TO
Rev.
TR Project No.: 02020 Page 43 of 193
Rev.
Mass Frac (%)
NBP365*
0,00
0,00
0,00
1,49
1,26
NBP375*
0,00
0,00
0,00
1,46
1,54
NBP385*
0,00
0,00
0,00
1,42
1,82
NBP395*
0,00
0,00
0,00
1,38
2,06
NBP405*
0,00
0,00
0,00
1,35
2,20
NBP415*
0,00
0,00
0,00
1,32
2,24
NBP425*
0,00
0,00
0,00
1,29
2,24
NBP435*
0,00
0,00
0,00
1,27
2,21
NBP445*
0,00
0,00
0,00
1,26
2,19
NBP455*
0,00
0,00
0,00
1,24
2,17
NBP470*
0,00
0,00
0,00
2,49
4,35
NBP490*
0,00
0,00
0,00
2,71
4,73
NBP510*
0,00
0,00
0,00
2,87
5,02
NBP530*
0,00
0,00
0,00
2,79
4,87
NBP550*
0,00
0,00
0,00
4,19
7,31
NBP570*
0,00
0,00
0,00
1,79
3,12
NBP590*
0,00
0,00
0,00
1,73
3,02
NBP610*
0,00
0,00
0,00
1,66
2,89
NBP630*
0,00
0,00
0,00
1,55
2,70
NBP660*
0,00
0,00
0,00
2,86
4,98
NBP700*
0,00
0,00
0,00
2,64
4,59
NBP740*
0,00
0,00
0,00
2,48
4,33
NBP780*
0,00
0,00
0,00
2,37
4,13
NBP820*
0,00
0,00
0,00
2,25
3,92
NBP860*
0,00
0,00
0,00
2,19
3,82
NBP900*
0,00
0,00
0,00
2,19
3,82
NBP940*
0,00
0,00
0,00
2,19
3,82
NBP980*
0,00
0,00
0,00
2,19
2,41
NOTES: (1) Cracking in the vacuum heater has been considered.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
78 VAC. RESIDUE
TO 011-G-0018 A/B
DESCRIPTION
Component
REV: 03 Date: 12-MAY-11
81
Rev.
TR Project No.: 02020 Page 44 of 193
84
85
87
HVGO TO 011-G-0017 A/B
MVGO TO 011-G-0016 A/B
MVGO + HVGO TO 011-E-0015 A/B
LVGO TO 011-G-0015 A/B
5,84E-03
Rev.
Mass Frac (%)
H2O
2,03E-03
2,14E-03
3,16E-03
2,51E-03
H2S
0,00
0,00
0,00
0,00
0,00
HYDROGEN
0,00
0,00
0,00
0,00
0,00 0,00
AIR
0,00
0,00
0,00
0,00
METHANE
0,00
0,00
0,00
0,00
0,00
ETHANE
0,00
0,00
0,00
0,00
0,00
ETHYLENE
0,00
0,00
0,00
0,00
0,00
PROPANE
0,00
0,00
0,00
0,00
0,00
PROPENE
0,00
0,00
0,00
0,00
0,00
IBUTANE
0,00
0,00
0,00
0,00
0,00 0,00
BUTANE
0,00
0,00
0,00
0,00
1-BUTENE
0,00
0,00
0,00
0,00
0,00
IPENTANE
0,00
0,00
0,00
0,00
0,00 1,73E-04
PENTANE
0,00
0,00
0,00
0,00
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
0,00
0,00
0,00
0,00
0,00 0,00
NBP45*
0,00
0,00
0,00
0,00
NBP55.*
0,00
0,00
0,00
0,00
0,00
NBP65*
0,00
0,00
0,00
0,00
0,00
NBP75*
0,00
0,00
0,00
0,00
0,00
NBP85*
0,00
0,00
0,00
0,00
0,00
NBP95*
0,00
0,00
0,00
0,00
0,00
NBP105*
0,00
0,00
0,00
0,00
0,00
NBP115*
0,00
1,44E-04
2,96E-04
1,99E-04
3,53E-03
NBP125*
0,00
2,58E-04
5,52E-04
3,64E-04
7,88E-03
NBP135*
0,00
3,96E-04
8,86E-04
5,72E-04
1,54E-02
NBP145*
0,00
5,21E-04
1,23E-03
7,75E-04
2,60E-02
NBP155*
0,00
7,20E-04
1,79E-03
1,11E-03
4,99E-02
NBP165*
0,00
9,12E-04
2,36E-03
1,43E-03
8,26E-02
NBP175*
0,00
1,12E-03
3,00E-03
1,80E-03
0,132
NBP185*
0,00
1,14E-03
3,20E-03
1,88E-03
0,197
NBP195*
0,00
1,19E-03
3,49E-03
2,01E-03
0,274
NBP205*
0,00
1,31E-03
4,00E-03
2,28E-03
0,390
NBP215*
0,00
1,41E-03
4,49E-03
2,52E-03
0,520
NBP225*
0,00
1,44E-03
4,75E-03
2,63E-03
0,621
NBP235*
0,00
1,53E-03
5,22E-03
2,86E-03
0,722
NBP245*
0,00
1,75E-03
6,18E-03
3,35E-03
0,853
NBP255*
0,00
1,88E-03
6,85E-03
3,67E-03
0,906
NBP265*
0,00
2,12E-03
7,99E-03
4,23E-03
0,970
NBP275*
0,00
2,78E-03
1,08E-02
5,66E-03
1,16
NBP285*
0,00
4,60E-03
1,84E-02
9,55E-03
1,62
NBP295*
0,00
7,97E-03
3,27E-02
1,69E-02
2,37
NBP305*
0,00
1,43E-02
6,00E-02
3,07E-02
3,49
NBP315*
0,00
2,62E-02
0,113
5,74E-02
5,18
NBP325*
0,00
4,69E-02
0,207
0,105
7,35
NBP335*
0,00
8,19E-02
0,374
0,187
9,98
NBP345*
0,00
0,139
0,664
0,327
12,7
NBP355*
0,00
0,231
1,21
0,585
15,3
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
78 VAC. RESIDUE
TO 011-G-0018 A/B
DESCRIPTION
Component
REV: 03 Date: 12-MAY-11
81
Rev.
TR Project No.: 02020 Page 45 of 193
84
85
87
HVGO TO 011-G-0017 A/B
MVGO TO 011-G-0016 A/B
MVGO + HVGO TO 011-E-0015 A/B
LVGO TO 011-G-0015 A/B
Rev.
Mass Frac (%)
NBP365*
0,00
0,376
2,41
1,11
16,2
NBP375*
0,00
0,609
5,14
2,24
12,4
NBP385*
0,00
0,963
8,82
3,79
5,03
NBP395*
0,00
1,42
10,8
4,81
1,13
NBP405*
1,72E-04
1,95
11,2
5,26
0,189
NBP415*
3,61E-04
2,51
10,5
5,39
2,72E-02
NBP425*
7,47E-04
3,10
9,45
5,38
3,55E-03
NBP435*
1,54E-03
3,71
8,19
5,32
4,30E-04
NBP445*
3,16E-03
4,33
6,94
5,27
0,00
NBP455*
6,50E-03
4,94
5,72
5,22
0,00
NBP470*
3,84E-02
11,6
8,28
10,4
0,00
NBP490*
0,167
14,4
5,35
11,2
0,00
NBP510*
0,617
16,0
3,05
11,3
0,00
NBP530*
2,33
13,3
0,813
8,84
0,00
NBP550*
6,57
14,6
0,473
9,52
0,00
NBP570*
4,22
3,59
6,17E-02
2,32
0,00
NBP590*
5,16
1,46
1,33E-02
0,939
0,00
NBP610*
5,44
0,419
2,02E-03
0,269
0,00
NBP630*
5,24
9,19E-02
2,32E-04
5,89E-02
0,00
NBP660*
9,76
1,52E-02
0,00
9,76E-03
0,00
NBP700*
9,00
4,66E-04
0,00
2,99E-04
0,00
NBP740*
8,47
0,00
0,00
0,00
0,00
NBP780*
8,09
0,00
0,00
0,00
0,00
NBP820*
7,68
0,00
0,00
0,00
0,00
NBP860*
7,49
0,00
0,00
0,00
0,00
NBP900*
7,49
0,00
0,00
0,00
0,00
NBP940*
7,49
0,00
0,00
0,00
0,00
NBP980*
4,72
0,00
0,00
0,00
0,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
90
DESCRIPTION
OFF GAS TO 011-C-0007
BRINE TO WWT
SOUR WATER TO SWS
Component
Rev.
91 (1)
Rev.
96 (2)
Rev.
TR Project No.: 02020 Page 46 of 193
97 LEAN AMINE
Rev.
98
Rev.
RICH AMINE
Mass Frac (%)
H2O
1,28
100,0
100,0
74,9
73,5
H2S
19,2
0,00
0,00
0,162
1,86
HYDROGEN
0,244
0,00
0,00
0,00
0,00
AIR
6,08
0,00
0,00
0,00
3,34E-04
METHANE
8,62
0,00
0,00
0,00
9,64E-04
ETHANE
8,01
0,00
0,00
0,00
1,11E-03
ETHYLENE
1,52
0,00
0,00
0,00
4,80E-04
PROPANE
10,9
0,00
0,00
0,00
1,24E-03
PROPENE
4,23
0,00
0,00
0,00
1,39E-03
IBUTANE
2,52
0,00
0,00
0,00
1,93E-04 1,29E-03
BUTANE
11,8
0,00
0,00
0,00
1-BUTENE
4,49
0,00
0,00
0,00
1,10E-03
IPENTANE
5,52
0,00
0,00
0,00
3,01E-04 5,81E-04
PENTANE
8,19
0,00
0,00
0,00
DEA
0,00
0,00
0,00
25,0
24,6
NBP38*
0,00
0,00
0,00
0,00
0,00 0,00
NBP45*
5,10E-03
0,00
0,00
0,00
NBP55.*
1,47
0,00
0,00
0,00
0,00
NBP65*
1,03
0,00
0,00
0,00
0,00
NBP75*
0,700
0,00
0,00
0,00
0,00
NBP85*
0,419
0,00
0,00
0,00
0,00
NBP95*
0,218
0,00
0,00
0,00
0,00
NBP105*
0,103
0,00
0,00
0,00
0,00
NBP115*
1,49
0,00
0,00
0,00
0,00
NBP125*
1,09
0,00
0,00
0,00
0,00
NBP135*
0,594
0,00
0,00
0,00
0,00
NBP145*
0,255
0,00
0,00
0,00
0,00
NBP155*
7,42E-02
0,00
0,00
0,00
0,00
NBP165*
2,35E-02
0,00
0,00
0,00
0,00
NBP175*
6,59E-03
0,00
0,00
0,00
0,00
NBP185*
7,49E-04
0,00
0,00
0,00
0,00
NBP195*
1,21E-04
0,00
0,00
0,00
0,00
NBP205*
0,00
0,00
0,00
0,00
0,00
NBP215*
0,00
0,00
0,00
0,00
0,00
NBP225*
0,00
0,00
0,00
0,00
0,00
NBP235*
0,00
0,00
0,00
0,00
0,00
NBP245*
0,00
0,00
0,00
0,00
0,00
NBP255*
0,00
0,00
0,00
0,00
0,00
NBP265*
0,00
0,00
0,00
0,00
0,00
NBP275*
0,00
0,00
0,00
0,00
0,00
NBP285*
0,00
0,00
0,00
0,00
0,00
NBP295*
0,00
0,00
0,00
0,00
0,00
NBP305*
0,00
0,00
0,00
0,00
0,00
NBP315*
0,00
0,00
0,00
0,00
0,00
NBP325*
0,00
0,00
0,00
0,00
0,00
NBP335*
0,00
0,00
0,00
0,00
0,00
NBP345*
0,00
0,00
0,00
0,00
0,00
NBP355*
0,00
0,00
0,00
0,00
0,00
NOTES: (1) For details of the dissolved species on this stream refer to pertinent vendor document. (2) This stream may contain up to 60 pmm of H2S. This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 47 of 193
STREAM Nº
90
DESCRIPTION
OFF GAS TO 011-C-0007
BRINE TO WWT
SOUR WATER TO SWS
LEAN AMINE
RICH AMINE
NBP365*
0,00
0,00
0,00
0,00
0,00
NBP375*
0,00
0,00
0,00
0,00
0,00
NBP385*
0,00
0,00
0,00
0,00
0,00
NBP395*
0,00
0,00
0,00
0,00
0,00
NBP405*
0,00
0,00
0,00
0,00
0,00
NBP415*
0,00
0,00
0,00
0,00
0,00
NBP425*
0,00
0,00
0,00
0,00
0,00
NBP435*
0,00
0,00
0,00
0,00
0,00
NBP445*
0,00
0,00
0,00
0,00
0,00
NBP455*
0,00
0,00
0,00
0,00
0,00
NBP470*
0,00
0,00
0,00
0,00
0,00
NBP490*
0,00
0,00
0,00
0,00
0,00
NBP510*
0,00
0,00
0,00
0,00
0,00
NBP530*
0,00
0,00
0,00
0,00
0,00
NBP550*
0,00
0,00
0,00
0,00
0,00
NBP570*
0,00
0,00
0,00
0,00
0,00
NBP590*
0,00
0,00
0,00
0,00
0,00
NBP610*
0,00
0,00
0,00
0,00
0,00
NBP630*
0,00
0,00
0,00
0,00
0,00
NBP660*
0,00
0,00
0,00
0,00
0,00
NBP700*
0,00
0,00
0,00
0,00
0,00
NBP740*
0,00
0,00
0,00
0,00
0,00
NBP780*
0,00
0,00
0,00
0,00
0,00
NBP820*
0,00
0,00
0,00
0,00
0,00
NBP860*
0,00
0,00
0,00
0,00
0,00
NBP900*
0,00
0,00
0,00
0,00
0,00
NBP940*
0,00
0,00
0,00
0,00
0,00
NBP980*
0,00
0,00
0,00
0,00
0,00
Component
Rev.
91 (1)
Rev.
96 (2)
Rev.
97
Rev.
98
Rev.
Mass Frac (%)
NOTES: (1) For details of the dissolved species on this stream refer to pertinent vendor document. (2) This stream may contain up to 60 pmm of H2S. This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
99
DESCRIPTION
REFLUX 011-C-0001
REFLUX 011-C-0002
H2O
0,258
5,93E-02
H2S
0,00
3,38E-02
HYDROGEN
0,00
0,00
AIR
0,00
0,00
METHANE
0,00
1,38E-03 3,83E-02
Component
Rev.
100
TR Project No.: 02020 Page 48 of 193
Rev.
Mass Frac (%)
ETHANE
1,11E-02
ETHYLENE
0,00
0,00
PROPANE
0,360
0,341
PROPENE
0,00
0,00
IBUTANE
0,283
0,366
BUTANE
1,49
1,56
1-BUTENE
0,00
0,00
IPENTANE
1,78
2,06
PENTANE
3,67
3,85
DEA
0,00
0,00
NBP38*
0,541
1,13
NBP45*
1,60
1,99
NBP55.*
2,14
2,56
NBP65*
3,00
3,46
NBP75*
4,24
4,74
NBP85*
5,86
6,36
NBP95*
7,58
8,02
NBP105*
9,51
9,82
NBP115*
11,4
11,4
NBP125*
13,1
12,4
NBP135*
13,9
11,9
NBP145*
12,4
9,95
NBP155*
5,48
5,64
NBP165*
1,18
1,89
NBP175*
0,173
0,406
NBP185*
1,31E-02
4,41E-02
NBP195*
1,33E-03
6,00E-03
NBP205*
1,30E-04
7,90E-04
NBP215*
0,00
1,01E-04
NBP225*
0,00
0,00
NBP235*
0,00
0,00
NBP245*
0,00
0,00
NBP255*
0,00
0,00
NBP265*
0,00
0,00
NBP275*
0,00
0,00
NBP285*
0,00
0,00
NBP295*
0,00
0,00
NBP305*
0,00
0,00
NBP315*
0,00
0,00
NBP325*
0,00
0,00
NBP335*
0,00
0,00
NBP345*
0,00
0,00
NBP355*
0,00
0,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
99
DESCRIPTION
REFLUX 011-C-0001
REFLUX 011-C-0002
NBP365*
0,00
0,00
NBP375*
0,00
0,00
NBP385*
0,00
0,00
NBP395*
0,00
0,00
NBP405*
0,00
0,00
NBP415*
0,00
0,00
NBP425*
0,00
0,00
NBP435*
0,00
0,00
NBP445*
0,00
0,00
NBP455*
0,00
0,00
NBP470*
0,00
0,00
NBP490*
0,00
0,00
NBP510*
0,00
0,00
NBP530*
0,00
0,00
NBP550*
0,00
0,00
NBP570*
0,00
0,00
NBP590*
0,00
0,00
NBP610*
0,00
0,00
NBP630*
0,00
0,00
NBP660*
0,00
0,00
NBP700*
0,00
0,00
NBP740*
0,00
0,00
NBP780*
0,00
0,00
NBP820*
0,00
0,00
NBP860*
0,00
0,00
NBP900*
0,00
0,00
NBP940*
0,00
0,00
NBP980*
0,00
0,00
Component
Rev.
100
TR Project No.: 02020 Page 49 of 193
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
3.2.2.
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 50 of 193
PHYSICAL PROPERTIES – BASE CASE. EPCC HEAT AND MATERIAL BALANCE STREAM Nº
1
DESCRIPTION
CRUDE
Rev.
2 WILD NAPHTHA
Rev.
3 TOTAL NAPHTHA
Rev.
4 KEROSENE TO LP HDS
Rev.
5
Rev.
KEROSENE TO STORAGE
----- TOTAL STREAM ----KG-MOL/HR
4743,9
90,5
1801,4
775,1
86,4
KG/HR
1179247,0
8500,0
156809,0
120112,0
13387,0
TEMPERATURE
°C
38,9
70,0
43,3
64,3
43,1
PRESSURE
BAR(GA)
2,0
5,0
7,0
7,0
7,0
248,6
93,9
87,1
155,0
155,0
RATE
MOLECULAR WEIGHT KCAL/KG
-503,4
-506,4
-533,4
-499,4
-510,5
KCAL/HR
-5,94E+08
-4,30E+06
-8,36E+07
-6,00E+07
-6,83E+06
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
4743,9
90,5
1801,4
775,1
86,4
KG/HR
1179247,0
8500,0
156809,0
120112,0
13387,0
M3/HR
1347,9
13,1
238,7
160,4
17,5
GAL(US)/MIN
5934,4
57,6
1051,1
706,1
77,0
M3/HR
1330,8
12,2
231,8
152,9
17,0
248,6
93,9
87,1
155,0
155,0
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-503,4
-506,4
-533,4
-499,4
-510,5
CP
KCAL/KG-C
0,457
0,582
0,564
0,535
0,512
DENSITY
KG/M3
874,9
649,9
656,8
748,9
765,4
0,033
0,030
0,040
0,059
0,062
Z FACTOR SURFACE TENSION
DYNE/CM
22,9
13,5
15,0
21,0
22,7
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,117
0,088
0,092
0,113
0,117
VISCOSITY
CP
9,3
0,3
0,3
0,7
0,9
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
6
DESCRIPTION
LAGO TO LP HDS
Rev.
7 LAGO TO STORAGE
Rev.
TR Project No.: 02020 Page 51 of 193
8+9 HAGO TO HP HDS/ STORAGE
Rev.
10+11 LVGO TO HP HDS/ STORAGE
Rev.
12
Rev.
HVGO TO DHC/MHC
----- TOTAL STREAM ----KG-MOL/HR
525,9
58,4
412,2
122,5
602,7
KG/HR
108302,6
12034,0
108877,1
33200,1
255165,0
TEMPERATURE
°C
50,2
50,2
50,0
50,0
163,3
PRESSURE
BAR(GA)
7,0
7,0
7,5
7,5
13,3
205,9
205,9
264,2
271,0
423,4
RATE
MOLECULAR WEIGHT KCAL/KG
-506,8
-506,8
-502,5
-499,9
-435,5
KCAL/HR
-5,49E+07
-6,10E+06
-5,47E+07
-1,66E+07
-1,11E+08
MOLE FRACTION LIQUID
0,991
0,991
0,991
1,000
1,000
MOLE FRACTION FREE WATER
0,009
0,009
0,009
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
525,9
58,4
412,2
122,5
602,7
KG/HR
108302,6
12034,0
108877,1
33200,1
255165,0
M3/HR
133,8
14,9
127,5
38,7
306,3
GAL(US)/MIN
589,3
65,5
561,2
170,4
1348,6
M3/HR
130,1
14,5
124,2
37,7
272,5
205,9
205,9
264,2
271,0
423,4
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-506,8
-506,8
-502,5
-499,9
-435,5
CP
KCAL/KG-C
0,494
0,494
0,466
0,464
0,566
DENSITY
KG/M3
809,2
809,2
854,2
857,7
833,0
-
-
-
0,100
0,200
Z FACTOR SURFACE TENSION
DYNE/CM
-
-
-
27,4
22,1
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,125
0,125
0,133
0,133
0,126
VISCOSITY
CP
2,2
2,2
5,9
6,2
3,4
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
13
DESCRIPTION
HVGO TO STORAGE
Rev.
14 VAC.RESIDUE TO STORAGE
Rev.
TR Project No.: 02020 Page 52 of 193
15 VAC. RESIDUE TO DCU
Rev.
16 PREFLASH OVERHEAD
Rev.
17
Rev.
NAPHTHA FROM PREFLASH
----- TOTAL STREAM ----KG-MOL/HR
67,0
40,4
364,1
2244,9
1578,4
KG/HR
28351,5
34745,3
313205,7
142837,2
88167,8
TEMPERATURE
°C
90,0
180,0
203,5
137,4
109,6
PRESSURE
BAR(GA)
7,0
7,0
10,2
3,7
3,0
423,4
860,3
860,3
63,6
55,9
RATE
MOLECULAR WEIGHT KCAL/KG
-474,4
-424,1
-411,0
-661,0
-747,6
KCAL/HR
-1,34E+07
-1,47E+07
-1,29E+08
-9,44E+07
-6,59E+07
MOLE FRACTION LIQUID
1,000
1,000
1,000
0,000
0,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
2244,9
1578,4
KG/HR
-
-
-
142837,2
88167,8
M3/HR
-
-
-
15116,5
11782,9
M3/HR
-
-
-
53079,9
37321,3
-
-
-
63,6
55,9
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-661,0
-747,6
CP
KCAL/KG-C
-
-
-
0,535
0,513
DENSITY
KG/M3
-
-
-
9,45
7,48
-
-
-
0,927
0,938
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
0,021
0,019
VISCOSITY
CP
-
-
-
0,01
0,01
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
67,0
40,4
364,1
-
-
KG/HR
28351,5
34745,3
313205,7
-
-
M3/HR
32,1
36,3
332,4
-
-
GAL(US)/MIN
141,5
159,7
1463,4
-
-
M3/HR
MOLECULAR WEIGHT
30,3
33,0
297,4
-
-
423,4
860,3
860,3
-
-
ENTHALPY
KCAL/KG
-474,4
-424,1
-411,0
-
-
CP
KCAL/KG-C
0,489
0,545
0,567
-
-
DENSITY
KG/M3
882,1
958,0
942,4
-
-
0,127
0,191
0,258
-
-
Z FACTOR SURFACE TENSION
DYNE/CM
26,5
24,8
23,7
-
-
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,137
0,144
0,141
-
-
VISCOSITY
CP
12,3
37,3
22,4
-
-
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
18
DESCRIPTION
TOPPED CRUDE
Rev.
19 CDU OVERHEAD
Rev.
TR Project No.: 02020 Page 53 of 193
20 ATM. RESIDUE
Rev.
21 VDU OVERHEAD
Rev.
22
Rev.
RECOVERED OIL
----- TOTAL STREAM ----KG-MOL/HR
3809,2
3176,7
1195,9
1516,7
54,3
KG/HR
1102675,7
201223,8
668168,5
34684,9
7977,1
TEMPERATURE
°C
186,8
119,7
351,2
83,2
50,3
PRESSURE
BAR(GA)
3,9
1,0
14,9
-0,9
7,5
289,5
63,3
558,7
22,9
146,9
RATE
MOLECULAR WEIGHT KCAL/KG
-426,8
-757,1
-317,1
-2478,5
-507,5
KCAL/HR
-4,71E+08
-1,52E+08
-2,12E+08
-8,60E+07
-4,05E+06
MOLE FRACTION LIQUID
1,000
0,000
1,000
0,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1)
KG-MOL/HR
-
3176,7
-
1516,7
-
KG/HR
-
201223,8
-
34684,9
-
M3/HR
-
49483,6
-
395868,3
-
M3/HR
-
75111,6
-
35862,4
-
-
63,3
-
22,9
-
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-757,1
-
-2478,5
-
CP
KCAL/KG-C
-
0,502
-
0,445
-
DENSITY
KG/M3
-
4,07
-
0,09
-
-
0,960
-
0,998
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
0,018
-
0,019
-
VISCOSITY
CP
-
0,01
-
0,01
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
3809,2
-
1195,9
-
54,3
KG/HR
1102675,7
-
668168,5
-
7977,1
M3/HR
1408,3
-
873,4
-
10,6
GAL(US)/MIN
6200,8
-
3845,3
-
46,6
M3/HR
1211,5
-
672,1
-
10,3
289,5
-
558,7
-
146,9
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-426,8
-
-317,1
-
-507,5
CP
KCAL/KG-C
0,599
-
0,701
-
0,524
DENSITY
KG/M3
783,0
-
765,1
-
753,3
0,047
-
0,224
-
0,062
Z FACTOR SURFACE TENSION
DYNE/CM
15,4
-
13,0
-
21,4
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,102
-
0,105
-
0,113
VISCOSITY
CP
1,3
-
0,9
-
0,8
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
23
DESCRIPTION
OFF GAS
Rev.
24 WASHED OFF GAS
Rev.
TR Project No.: 02020 Page 54 of 193
25 HAGO+LVGO TO HP HDS
Rev.
26 HAGO+LVGO TO STORAGE
Rev.
27
Rev.
FRESH CRUDE TO 011-E-0002
----- TOTAL STREAM ----KG-MOL/HR
22,8
16,8
555,4
33,6
4743,9
KG/HR
871,5
599,0
141500,0
8554,3
1179247,0
TEMPERATURE
°C
50,0
65,0
50,0
50,0
51,6
PRESSURE
BAR(GA)
0,3
1,8
7,5
7,0
26,2
38,2
35,7
254,8
254,8
248,6
RATE
MOLECULAR WEIGHT KCAL/KG
-527,8
-568,8
-502,2
-502,2
-497,0
KCAL/HR
-4,60E+05
-3,41E+05
-7,11E+07
-4,30E+06
-5,86E+08
MOLE FRACTION LIQUID
0,000
0,000
0,994
0,994
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,006
0,006
0,000
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1)
KG-MOL/HR
22,8
16,8
-
-
-
KG/HR
871,5
599,0
-
-
-
M3/HR
466,8
164,6
-
-
-
M3/HR
539,4
396,7
-
-
-
38,2
35,7
-
-
-
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-527,8
-568,8
-
-
-
CP
KCAL/KG-C
0,404
0,449
-
-
-
DENSITY
KG/M3
1,87
3,64
-
-
-
0,990
0,982
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,021
0,025
-
-
-
VISCOSITY
CP
0,01
0,01
-
-
-
KG-MOL/HR
-
-
555,4
33,6
4743,9
KG/HR
-
-
141500,0
8554,3
1179247,0
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
M3/HR
-
-
166,6
10,1
1359,3
GAL(US)/MIN
-
-
733,4
44,3
5984,8
M3/HR
-
-
162,4
9,8
1330,8
-
-
254,8
254,8
248,6
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-502,2
-502,2
-497,0
CP
KCAL/KG-C
-
-
0,469
0,469
0,471
DENSITY
KG/M3
-
-
849,5
849,4
867,5
-
-
-
-
0,289
Z FACTOR SURFACE TENSION
DYNE/CM
-
-
-
-
21,8
THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
0,131
0,131
0,115
VISCOSITY
CP
-
-
5,4
5,4
7,5
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
REV: 03 Date: 12-MAY-11
28
DESCRIPTION
Rev.
29
FRESH CRUDE TO
FRESH CRUDE TO
011-E-0003 A/D
011-E-0004 A/B
Rev.
TR Project No.: 02020 Page 55 of 193
30 FRESH CRUDE TO 011-E-0005
Rev.
31 FRESH CRUDE TO 011-E-0006
Rev.
32
Rev.
FRESH CRUDE TO 011-E-0007 A/D
----- TOTAL STREAM ----KG-MOL/HR
4743,9
4743,9
4743,9
4743,9
4743,9
KG/HR
1179247,0
1179247,0
1179247,0
1179247,0
1179247,0
TEMPERATURE
°C
57,8
79,7
91,5
97,0
105,0
PRESSURE
BAR(GA)
25,5
22,3
20,5
19,6
18,8
248,6
248,6
248,6
248,6
248,6
RATE
MOLECULAR WEIGHT KCAL/KG
-494,1
-483,4
-477,4
-474,6
-470,4
KCAL/HR
-5,83E+08
-5,70E+08
-5,63E+08
-5,60E+08
-5,55E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
4743,9
4743,9
4743,9
4743,9
4743,9
KG/HR
1179247,0
1179247,0
1179247,0
1179247,0
1179247,0
M3/HR
1367,0
1395,1
1411,0
1418,6
1429,8
GAL(US)/MIN
6018,8
6142,5
6212,5
6246,0
6295,3
M3/HR
1330,8
1330,8
1330,8
1330,8
1330,8
248,6
248,6
248,6
248,6
248,6
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-494,1
-483,4
-477,4
-474,6
-470,4
CP
KCAL/KG-C
0,478
0,503
0,516
0,521
0,530
DENSITY
KG/M3
862,6
845,3
835,7
831,3
824,8
0,278
0,234
0,211
0,200
0,190
Z FACTOR SURFACE TENSION
DYNE/CM
21,3
19,6
18,7
18,2
17,7
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,113
0,109
0,106
0,105
0,103
VISCOSITY
CP
6,7
4,6
3,6
3,2
2,8
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
REV: 03 Date: 12-MAY-11
33 FRESH CRUDE TO 011-E-0008
DESCRIPTION
Rev.
34 FRESH CRUDE TO 011-E-0009
Rev.
TR Project No.: 02020 Page 56 of 193
35 FRESH CRUDE TO DESALTER 011-X-0002
Rev.
36 DESALTED CRUDE TO 011-G-0002 A/B
Rev.
37
Rev.
DESALTED CRUDE TO 011-E-0011A/B 011-E-0012A/B
----- TOTAL STREAM ----KG-MOL/HR
4743,9
4743,9
4743,9
5293,4
5293,4
KG/HR
1179247,0
1179247,0
1179247,0
1189145,4
1189145,4
TEMPERATURE
°C
131,0
140,9
151,3
145,0
157,1
PRESSURE
BAR(GA)
16,2
15,6
15,1
12,0
32,6
248,6
248,6
248,6
224,6
224,6
RATE
MOLECULAR WEIGHT KCAL/KG
-456,3
-450,8
-444,9
-475,2
-467,9
KCAL/HR
-5,38E+08
-5,32E+08
-5,25E+08
-5,65E+08
-5,56E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
0,930
0,942
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,070
0,058
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
4743,9
4743,9
4743,9
5293,4
5293,4
KG/HR
1179247,0
1179247,0
1179247,0
1189145,4
1189145,4
M3/HR
1468,2
1483,7
1500,3
1498,5
1510,8
GAL(US)/MIN
6464,2
6532,4
6605,7
6597,6
6651,8
M3/HR
1330,8
1330,8
1330,8
1340,7
1340,7
248,6
248,6
248,6
224,6
224,6
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-456,3
-450,8
-444,9
-475,2
-467,9
CP
KCAL/KG-C
0,555
0,564
0,574
0,572
0,582
DENSITY
KG/M3
803,2
794,8
786,0
793,6
787,1
0,159
0,151
0,144
-
-
Z FACTOR SURFACE TENSION
DYNE/CM
15,8
15,0
14,3
-
-
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,097
0,093
0,089
0,102
0,098
VISCOSITY
CP
1,9
1,6
1,4
1,5
1,3
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
38
DESCRIPTION
DESALTED CRUDE TO 011-E-0013
Rev.
39 DESALTED CRUDE TO 011-E-0014 A/F
Rev.
TR Project No.: 02020 Page 57 of 193
40 DESALTED CRUDE TO 011-FV-0006
Rev.
41 DESALTED CRUDE TO 011-C-0001
Rev.
42
Rev.
PREFLASH OVERHEAD TO 011-D-0003
----- TOTAL STREAM ----KG-MOL/HR
5293,4
5293,4
5293,4
5293,4
2244,9
KG/HR
1189145,4
1189145,4
1189145,4
1189145,4
142837,2
TEMPERATURE
°C
167,7
179,3
200,0
188,8
109,6
PRESSURE
BAR(GA)
31,3
30,4
28,4
3,9
3,0
224,6
224,6
224,6
224,6
63,6
RATE
MOLECULAR WEIGHT KCAL/KG
-461,8
-454,8
-442,3
-442,3
-710,8
KCAL/HR
-5,49E+08
-5,41E+08
-5,26E+08
-5,26E+08
-1,02E+08
MOLE FRACTION LIQUID
0,955
1,000
1,000
0,733
0,228
MOLE FRACTION FREE WATER
0,045
0,000
0,000
0,000
0,069
KG-MOL/HR
-
-
-
1413,5
1578,4
KG/HR
-
-
-
85330,2
88167,8
M3/HR
-
-
-
10633,3
11782,9
M3/HR
-
-
-
33421,2
37321,3
-
-
-
60,4
55,9
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-677,0
-747,6
CP
KCAL/KG-C
-
-
-
0,564
0,513
DENSITY
KG/M3
-
-
-
8,02
7,48
-
-
-
0,952
0,938
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
0,026
0,019
VISCOSITY
CP
-
-
-
0,01
0,01
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
5293,4
5293,4
5293,4
3879,9
666,5
KG/HR
1189145,4
1189145,4
1189145,4
1103815,2
54669,4
M3/HR
1527,5
1544,0
1583,2
1420,5
85,5
GAL(US)/MIN
6725,5
6798,1
6970,5
6254,1
376,6
M3/HR
1340,7
1340,7
1340,7
1217,0
75,6
224,6
224,6
224,6
284,5
82,0
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-461,8
-454,8
-442,3
-424,1
-651,5
CP
KCAL/KG-C
0,591
0,601
0,618
0,601
0,634
DENSITY
KG/M3
778,5
770,2
751,1
777,1
639,2
-
0,244
0,224
0,046
-
Z FACTOR SURFACE TENSION
DYNE/CM
-
15,6
14,0
14,4
-
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,098
0,106
0,094
0,094
0,092
VISCOSITY
CP
1,2
1,0
0,8
1,2
0,2
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
43
DESCRIPTION
MPS TO 011-C-0001
Rev.
44
Rev.
TR Project No.: 02020 Page 58 of 193
45 (2)
Rev.
46 (2)
Rev.
47
TOPPED CRUDE TO
TOPPED CRUDE TO
TOPPED CRUDE TO
TOPPED CRUDE TO
011-E-0016 A/B
011-E-0017 A/B
011-E-0018 A/B
011-E-0019 A/F
Rev.
----- TOTAL STREAM ----KG-MOL/HR
249,8
3809,2
3809,2
3809,2
3809,2
KG/HR
4500,0
1102675,7
1102675,7
1102675,7
1102675,7
TEMPERATURE
°C
250,0
201,1
222,4
230,5
243,9
PRESSURE
BAR(GA)
14,5
33,5
32,5
32,0
30,6
18,0
289,5
289,5
289,5
289,5
RATE
MOLECULAR WEIGHT KCAL/KG
-3103,7
-417,8
-404,7
-399,5
-391,0
KCAL/HR
-1,40E+07
-4,61E+08
-4,46E+08
-4,41E+08
-4,31E+08
MOLE FRACTION LIQUID
0,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
ENTHALPY
----- TOTAL VAPOR -----RATE
KG-MOL/HR
249,8
-
-
-
-
KG/HR
4500,0
-
-
-
-
M3/HR
662,7
-
-
-
-
M3/HR
5906,2
-
-
-
-
18,0
-
-
-
-
ENTHALPY
KCAL/KG
-3103,7
-
-
-
-
CP
KCAL/KG-C
0,580
-
-
-
-
DENSITY
KG/M3
6,79
-
-
-
-
0,945
-
-
-
-
STD. VAPOR RATE (1) MOLECULAR WEIGHT
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,035
-
-
-
-
VISCOSITY
CP
0,02
-
-
-
-
KG-MOL/HR
-
3809,2
3809,2
3809,2
3809,2
KG/HR
-
1102675,7
1102675,7
1102675,7
1102675,7
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
M3/HR
-
1420,5
1453,0
1466,1
1488,9
GAL(US)/MIN
-
6254,1
6397,3
6455,2
6555,3
M3/HR
-
1211,5
1211,5
1211,5
1211,5
-
289,5
289,5
289,5
289,5
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-417,8
-404,7
-399,5
-391,0
CP
KCAL/KG-C
-
0,609
0,627
0,633
0,644
DENSITY
KG/M3
-
776,3
758,9
752,1
740,6
-
0,326
0,310
0,303
0,287
Z FACTOR SURFACE TENSION
DYNE/CM
-
14,4
13,0
12,4
11,6
THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
0,097
0,090
0,088
0,083
VISCOSITY
CP
-
1,1
0,9
0,8
0,7
NOTES: (1) Standard conditions: 15°C and 1 atm. (2) Total flowrate through heat exchangers has been considered on the Heat and Material Balance for this stream.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
REV: 03 Date: 12-MAY-11
48 TOPPED CRUDE TO
DESCRIPTION
011-E-0020 A/F
Rev.
49 TOPPED CRUDE TO 011-F-0001
Rev.
TR Project No.: 02020 Page 59 of 193
50 TOPPED CRUDE TO 011-C-0002
Rev.
51 HAGO PA TO 011-G-0012 A/B
Rev.
52
Rev.
HAGO PA TO 011-C-0002
----- TOTAL STREAM ----KG-MOL/HR
3809,2
3809,2
3814,4
3533,0
2631,8
KG/HR
1102675,7
1102675,7
1102675,7
892154,0
664599,5
TEMPERATURE
°C
275,4
297,9
366,0
307,6
261,1
PRESSURE
BAR(GA)
28,6
26,4
2,0
1,4
1,4
289,5
289,5
289,5
252,5
252,5
RATE
MOLECULAR WEIGHT KCAL/KG
-370,4
-355,2
-292,9
-348,0
-379,8
KCAL/HR
-4,08E+08
-3,92E+08
-3,23E+08
-3,10E+08
-2,52E+08
MOLE FRACTION LIQUID
1,000
1,000
0,417
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
2222,2
-
-
KG/HR
-
-
359624,5
-
-
M3/HR
-
-
37071,3
-
-
M3/HR
-
-
52543,2
-
-
-
-
161,8
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-268,7
-
-
CP
KCAL/KG-C
-
-
0,685
-
-
DENSITY
KG/M3
-
-
9,70
-
-
-
-
0,946
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
0,031
-
-
VISCOSITY
CP
-
-
0,01
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
3809,2
3809,2
1592,1
3533,0
2631,8
KG/HR
1102675,7
1102675,7
744546,8
892154,0
664599,5
M3/HR
1547,1
1595,1
1036,8
1377,7
965,9
GAL(US)/MIN
6811,7
7023,1
4564,9
6065,9
4252,7
M3/HR
1211,5
1211,5
765,6
1027,1
765,1
289,5
289,5
467,6
252,5
252,5
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-370,4
-355,2
-304,7
-348,0
-379,8
CP
KCAL/KG-C
0,668
0,685
0,717
0,703
0,668
DENSITY
KG/M3
712,7
691,3
718,1
647,6
688,1
0,264
0,242
0,037
0,020
0,020
Z FACTOR SURFACE TENSION
DYNE/CM
9,7
8,4
10,0
9,4
12,2
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,072
0,063
0,078
0,081
0,092
VISCOSITY
CP
0,5
0,4
0,6
0,2
0,3
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
53
DESCRIPTION
HAGO TO 011-C-0006
Rev.
54 HAGO TO 011-G-0013 A/B
Rev.
TR Project No.: 02020 Page 60 of 193
55 HAGO TO 011-E-0009 A/B
Rev.
56 HAGO TO 011-E-0002
Rev.
57
Rev.
HAGO TO 011-A-0004
----- TOTAL STREAM ----KG-MOL/HR
527,3
412,2
412,2
412,2
412,2
KG/HR
133160,9
108877,1
108877,1
108877,1
108877,1
TEMPERATURE
°C
307,6
293,6
257,2
154,8
96,6
PRESSURE
BAR(GA)
1,4
1,5
13,2
12,2
11,5
252,5
264,2
264,2
264,2
264,2
RATE
MOLECULAR WEIGHT KCAL/KG
-348,0
-359,5
-384,0
-447,5
-479,4
KCAL/HR
-4,63E+07
-3,91E+07
-4,18E+07
-4,87E+07
-5,22E+07
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
0,999
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,001
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
527,3
412,2
412,2
412,2
412,2
KG/HR
133160,9
108877,1
108877,1
108877,1
108877,1
M3/HR
205,6
162,1
154,6
139,3
132,3
GAL(US)/MIN
905,4
713,5
680,6
613,4
582,7
M3/HR
153,3
124,2
124,2
124,2
124,2
252,5
264,2
264,2
264,2
264,2
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-348,0
-359,5
-384,0
-447,5
-479,4
CP
KCAL/KG-C
0,703
0,690
0,661
0,577
0,519
DENSITY
KG/M3
647,6
671,8
704,3
781,5
822,7
0,020
0,021
0,121
0,126
-
Z FACTOR SURFACE TENSION
DYNE/CM
9,4
11,0
13,3
20,3
-
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,081
0,091
0,099
0,118
0,127
VISCOSITY
CP
0,2
0,2
0,3
0,9
2,3
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
REV: 03 Date: 12-MAY-11
58 HAGO TO 011-E-0035
DESCRIPTION
Rev.
59 LAGO PA TO 011-G-0010 A/B
Rev.
TR Project No.: 02020 Page 61 of 193
60 LAGO PA TO 011-C-0002
Rev.
61 LAGO TO 011-C-0005
Rev.
62
Rev.
LAGO TO 011-G-0011 A/B
----- TOTAL STREAM ----KG-MOL/HR
412,2
4484,8
3519,8
721,6
584,4
KG/HR
108877,1
892919,6
700797,0
143660,5
120336,6
TEMPERATURE
°C
65,0
247,7
202,8
247,7
234,3
PRESSURE
BAR(GA)
10,8
1,3
1,3
1,3
1,3
264,2
199,1
199,1
199,1
205,9
RATE
MOLECULAR WEIGHT KCAL/KG
-495,3
-388,5
-418,1
-388,5
-399,3
KCAL/HR
-5,39E+07
-3,47E+08
-2,93E+08
-5,58E+07
-4,81E+07
MOLE FRACTION LIQUID
0,992
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,008
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
412,2
4484,8
3519,8
721,6
584,4
KG/HR
108877,1
892919,6
700797,0
143660,5
120336,6
M3/HR
129,0
1385,5
1024,1
222,9
180,9
GAL(US)/MIN
567,8
6100,0
4508,9
981,4
796,4
M3/HR
124,2
1080,0
847,6
173,8
144,5
264,2
199,1
199,1
199,1
205,9
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-495,3
-388,5
-418,1
-388,5
-399,3
CP
KCAL/KG-C
0,484
0,677
0,641
0,677
0,664
DENSITY
KG/M3
844,2
644,5
684,3
644,5
665,3
-
0,016
0,017
0,016
0,017
Z FACTOR SURFACE TENSION
DYNE/CM
-
10,4
13,5
10,4
12,0
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,131
0,084
0,095
0,084
0,092
VISCOSITY
CP
4,5
0,2
0,3
0,2
0,2
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
63
DESCRIPTION
LAGO TO 011-E-0006
Rev.
64 LAGO TO 011-E-0024
Rev.
TR Project No.: 02020 Page 62 of 193
65 LAGO TO 011-A-0003 A/B
Rev.
66 LAGO TO 011-E-0034
Rev.
67
Rev.
KERO PA TO 011-G-0008 A/B
----- TOTAL STREAM ----KG-MOL/HR
584,4
584,4
584,4
584,4
4802,6
KG/HR
120336,6
120336,6
120336,6
120336,6
708355,8
TEMPERATURE
°C
175,4
105,1
85,5
64,8
174,3
PRESSURE
BAR(GA)
13,3
12,6
12,1
11,4
1,1
205,9
205,9
205,9
205,9
147,5
RATE
MOLECULAR WEIGHT KCAL/KG
-436,8
-477,9
-488,5
-499,3
-437,5
KCAL/HR
-5,26E+07
-5,75E+07
-5,88E+07
-6,01E+07
-3,10E+08
MOLE FRACTION LIQUID
1,000
1,000
0,996
0,992
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,004
0,008
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
584,4
584,4
584,4
584,4
4802,6
KG/HR
120336,6
120336,6
120336,6
120336,6
708355,8
M3/HR
168,0
156,3
153,4
150,6
1094,4
GAL(US)/MIN
739,6
688,0
675,6
663,1
4818,7
M3/HR
144,5
144,5
144,5
144,5
909,8
205,9
205,9
205,9
205,9
147,5
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-436,8
-477,9
-488,5
-499,3
-437,5
CP
KCAL/KG-C
0,615
0,552
0,532
0,510
0,638
DENSITY
KG/M3
716,4
770,1
784,3
799,1
647,2
0,110
0,116
-
-
0,013
Z FACTOR SURFACE TENSION
DYNE/CM
16,2
21,5
-
-
11,8
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,104
0,118
0,120
0,123
0,089
VISCOSITY
CP
0,4
0,9
1,2
1,7
0,2
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
REV: 03 Date: 12-MAY-11
68 KERO PA TO 011-C-0002
DESCRIPTION
Rev.
69 KERO TO 011-C-0005
Rev.
TR Project No.: 02020 Page 63 of 193
70 KERO TO 011-G-0009 A/B
Rev.
71 KERO TO 011-E-0001
----- TOTAL STREAM -----
Rev.
72
KG-MOL/HR
3936,4
1122,3
861,5
861,5
3176,7
KG/HR
580595,5
165538,0
133499,0
133499,0
201223,8
TEMPERATURE
°C
128,1
174,3
220,7
144,9
94,7
PRESSURE
BAR(GA)
1,1
1,1
1,2
11,0
0,6
147,5
147,5
155,0
155,0
63,3
RATE
MOLECULAR WEIGHT KCAL/KG
-466,1
-437,5
-404,6
-453,2
-815,7
KCAL/HR
-2,71E+08
-7,24E+07
-5,40E+07
-6,05E+07
-1,64E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
0,232
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,108
KG-MOL/HR
-
-
-
-
2095,2
KG/HR
-
-
-
-
113413,2
M3/HR
-
-
-
-
38416,7
M3/HR
-
-
-
-
49540,1
-
-
-
-
54,1
ENTHALPY
Rev.
CDU OVERHEAD TO 011-A-0001 A/H
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-892,7
CP
KCAL/KG-C
-
-
-
-
0,484
DENSITY
KG/M3
-
-
-
-
2,95
-
-
-
-
0,967
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
0,017
VISCOSITY
CP
-
-
-
-
0,01
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
3936,4
1122,3
861,5
861,5
1081,5
KG/HR
580595,5
165538,0
133499,0
133499,0
87810,7
M3/HR
842,7
255,8
218,5
195,3
130,1
GAL(US)/MIN
3710,4
1126,1
962,1
859,7
572,6
M3/HR
745,7
212,6
170,0
170,0
118,2
147,5
147,5
155,0
155,0
81,2
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-466,1
-437,5
-404,6
-453,2
-716,2
CP
KCAL/KG-C
0,598
0,638
0,675
0,608
0,622
DENSITY
KG/M3
689,0
647,2
611,0
683,7
675,2
0,014
0,013
0,014
0,078
-
Z FACTOR SURFACE TENSION
DYNE/CM
15,4
11,8
8,8
14,5
-
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,099
0,089
0,079
0,096
0,102
VISCOSITY
CP
0,3
0,2
0,2
0,3
0,3
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 64 of 193
STREAM Nº
73
74
75
76
DESCRIPTION
CDU OVERHEAD TO 011-D-0004
PREFLASH NAPHTHA FROM 011-E-0021
NAPHTHA TO 011-E-0021
NAPHTHA TO 011-D-0005
Rev.
77 (2)
Rev.
ATM. RESIDUE TO 011-C-0003
----- TOTAL STREAM ----KG-MOL/HR
3176,7
1578,4
2359,8
2359,8
1736,4
KG/HR
201223,8
88167,8
166869,0
166869,0
681752,5
TEMPERATURE
°C
64,0
65,0
71,2
43,0
407,0
PRESSURE
BAR(GA)
0,3
2,5
2,5
1,8
-0,6
63,3
55,9
70,7
70,7
392,6
RATE
MOLECULAR WEIGHT KCAL/KG
-922,4
-885,8
-707,7
-728,3
-297,2
KCAL/HR
-1,86E+08
-7,81E+07
-1,18E+08
-1,22E+08
-2,03E+08
MOLE FRACTION LIQUID
0,546
0,498
0,720
0,763
0,391
MOLE FRACTION FREE WATER
0,450
0,341
0,230
0,237
0,000
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1)
KG-MOL/HR
11,0
254,8
117,9
-
1056,7
KG/HR
632,3
14259,1
6419,3
-
208100,0
M3/HR
229,7
1924,9
912,1
-
145342,4
M3/HR
260,8
6025,1
2787,3
-
24986,0
57,3
56,0
54,5
-
196,9
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-622,2
-561,0
-579,6
-
-344,1
CP
KCAL/KG-C
0,448
0,467
0,470
-
0,684
DENSITY
KG/M3
2,75
7,41
7,04
-
1,43
0,975
0,940
0,946
-
0,989
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,016
0,017
0,018
-
0,030
VISCOSITY
CP
0,01
0,01
0,01
-
0,01
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
3165,7
1323,6
2241,9
2359,8
679,7
KG/HR
200591,5
73908,7
160449,7
166869,0
473652,5
M3/HR
288,0
113,7
248,1
249,0
623,5
GAL(US)/MIN
1267,9
500,7
1092,5
1096,5
2745,2
M3/HR
272,4
106,5
230,9
241,9
463,5
63,4
55,8
71,6
70,7
696,9
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-923,4
-948,4
-712,8
-728,3
-276,6
CP
KCAL/KG-C
0,628
0,647
0,615
0,591
0,733
DENSITY
KG/M3
696,6
650,0
646,6
670,0
759,7
-
-
-
-
0,007
Z FACTOR SURFACE TENSION
DYNE/CM
-
-
-
-
12,4
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,110
0,098
0,092
0,098
0,102
VISCOSITY
CP
0,4
0,3
0,3
0,3
0,9
NOTES: (1) Standard conditions: 15°C and 1 atm. (2) Cracking in the vacuum heater has been considered.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
REV: 03 Date: 12-MAY-11
78
79
80
81
VAC. RESIDUE
VAC. RESIDUE TO 011-E-0018 A/D
VAC. RESIDUE TO 011-E-0014 A/F
HVGO TO 011-G-0017 A/B
TO 011-G-0018 A/B
DESCRIPTION
TR Project No.: 02020 Page 65 of 193
Rev.
82
Rev.
HVGO TO 011-E-0016 A/B
----- TOTAL STREAM ----KG-MOL/HR
534,9
534,9
404,5
2273,0
1708,7
KG/HR
460151,3
460151,3
347951,0
1057648,0
795048,0
TEMPERATURE
°C
360,2
308,0
275,2
320,9
280,0
PRESSURE
BAR(GA)
-0,8
16,5
15,5
-0,9
19,4
860,3
860,3
860,3
465,3
465,3
RATE
MOLECULAR WEIGHT KCAL/KG
-311,7
-346,8
-367,9
-335,4
-362,9
KCAL/HR
-1,43E+08
-1,60E+08
-1,28E+08
-3,55E+08
-2,89E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
534,9
534,9
404,5
2273,0
1708,7
KG/HR
460151,3
460151,3
347951,0
1057648,0
795048,0
M3/HR
550,0
527,5
389,0
1450,1
1044,5
GAL(US)/MIN
2421,6
2322,4
1712,6
6384,6
4598,6
M3/HR
436,9
436,9
330,4
1118,0
840,4
860,3
860,3
860,3
465,3
465,3
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-311,7
-346,8
-367,9
-335,4
-362,9
CP
KCAL/KG-C
0,695
0,656
0,630
0,695
0,664
DENSITY
KG/M3
836,6
872,4
894,5
729,4
761,2
0,003
0,357
0,348
0,002
0,271
Z FACTOR SURFACE TENSION
DYNE/CM
16,4
18,8
20,3
14,0
16,2
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,120
0,127
0,132
0,104
0,111
VISCOSITY
CP
2,7
5,4
7,6
0,6
0,9
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 66 of 193
STREAM Nº
83
84
85
86
DESCRIPTION
HVGO FROM 011-E-0016 A/B
MVGO TO 011-G-0016 A/B
MVGO + HVGO TO 011-E-0015 A/B
MVGO + HVGO TO 011-E-0010 A/B
Rev.
87
Rev.
LVGO TO 011-G-0015 A/B
----- TOTAL STREAM ----KG-MOL/HR
390,1
279,5
669,6
669,6
1864,4
KG/HR
181516,6
101999,8
283516,5
283516,5
505212,4
TEMPERATURE
°C
251,6
266,8
257,4
209,2
145,8
PRESSURE
BAR(GA)
18,7
-0,9
17,0
15,6
-0,9
465,3
364,9
423,4
423,4
271,0
RATE
MOLECULAR WEIGHT KCAL/KG
-381,4
-373,5
-378,3
-408,5
-450,5
KCAL/HR
-6,92E+07
-3,81E+07
-1,07E+08
-1,16E+08
-2,28E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
390,1
279,5
669,6
669,6
1864,4
KG/HR
181516,6
101999,8
283516,5
283516,5
505212,4
M3/HR
232,3
136,7
369,2
353,7
639,7
GAL(US)/MIN
1023,0
602,0
1625,5
1557,2
2816,4
M3/HR
191,9
110,9
302,8
302,8
574,2
465,3
364,9
423,4
423,4
271,0
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-381,4
-373,5
-378,3
-408,5
-450,5
CP
KCAL/KG-C
0,642
0,656
0,647
0,607
0,567
DENSITY
KG/M3
781,2
746,0
767,9
801,6
789,8
0,269
0,002
0,225
0,219
0,001
Z FACTOR SURFACE TENSION
DYNE/CM
17,7
15,1
16,7
19,4
20,7
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,115
0,106
0,112
0,119
0,117
VISCOSITY
CP
1,2
0,6
0,9
1,6
1,1
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 67 of 193
STREAM Nº
88
89
90
91
DESCRIPTION
LVGO TO 011-A-0005 A/H
LVGO TO 011-A-0005 A/H
OFF GAS TO 011-C-0007
BRINE TO WWT
Rev.
92
Rev.
HAGO PA TO NHDT UNIT
----- TOTAL STREAM ----KG-MOL/HR
1519,8
1519,8
19,9
5270,5
2368,5
KG/HR
411812,4
411812,4
721,5
95100,0
598100,0
TEMPERATURE
°C
126,5
60,0
41,5
41,5
307,6
PRESSURE
BAR(GA)
10,8
9,0
2,1
9,0
13,6
271,0
271,0
36,2
18,0
252,5
RATE
MOLECULAR WEIGHT KCAL/KG
-461,1
-495,2
-438,5
-3767,4
-347,9
KCAL/HR
-1,90E+08
-2,04E+08
-3,16E+05
-3,58E+08
-2,08E+08
MOLE FRACTION LIQUID
1,000
1,000
0,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
1,000
0,000
KG-MOL/HR
-
-
19,9
-
-
KG/HR
-
-
721,5
-
-
M3/HR
-
-
164,5
-
-
M3/HR
-
-
471,4
-
-
-
-
36,2
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-438,5
-
-
CP
KCAL/KG-C
-
-
0,398
-
-
DENSITY
KG/M3
-
-
4,39
-
-
-
-
0,978
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
0,021
-
-
VISCOSITY
CP
-
-
0,01
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
1519,8
1519,8
-
5270,5
2368,5
KG/HR
411812,4
411812,4
-
95100,0
598100,0
M3/HR
511,7
483,9
-
95,8
0,3
GAL(US)/MIN
2252,9
2130,8
-
421,7
1,1
M3/HR
468,0
468,0
-
95,2
688,5
271,0
271,0
-
18,0
252,5
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-461,1
-495,2
-
-3767,4
-347,9
CP
KCAL/KG-C
0,548
0,476
-
0,994
2,937
DENSITY
KG/M3
804,8
850,9
-
993,0
650,7
0,120
0,115
-
0,007
0,109
Z FACTOR SURFACE TENSION
DYNE/CM
22,0
26,7
-
69,6
9,4
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,121
0,131
-
0,540
0,094
VISCOSITY
CP
1,5
5,3
-
0,7
0,2
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 68 of 193
STREAM Nº
93
94 (2)
95 (2)
96
DESCRIPTION
HAGO PA FROM NHDT UNIT
LAGO PA TO NHDT UNIT
LAGO PA FROM NHDT UNIT
SOUR WATER TO SWS
Rev.
97
Rev.
LEAN AMINE
----- TOTAL STREAM ----KG-MOL/HR
2368,5
1933,7
1933,7
4252,5
351,9
KG/HR
598100,0
385000,0
385000,0
76610,0
8000,0
TEMPERATURE
°C
287,0
229,0
179,0
56,0
65,0
PRESSURE
BAR(GA)
11,1
11,6
9,1
7,0
2,0
252,5
199,1
199,1
18,0
22,7
RATE
MOLECULAR WEIGHT KCAL/KG
-362,2
-401,0
-433,0
-3748,3
-3076,9
KCAL/HR
-2,17E+08
-1,54E+08
-1,67E+08
-2,87E+08
-2,46E+07
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
1,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
2368,5
1933,7
1933,7
4252,5
351,9
KG/HR
598100,0
385000,0
385000,0
76610,0
8000,0
M3/HR
0,2
0,2
0,2
77,8
7,9
GAL(US)/MIN
1,1
0,7
0,7
342,5
34,9
M3/HR
688,5
465,7
465,7
76,8
7,8
252,5
199,1
199,1
18,0
22,7 -3076,9
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-362,2
-401,0
-433,0
-3748,3
CP
KCAL/KG-C
2,874
2,766
2,596
1,007
0,903
DENSITY
KG/M3
668,1
663,5
705,3
984,9
1009,8 0,002
0,090
0,083
0,068
0,005
SURFACE TENSION
DYNE/CM
10,6
11,6
15,2
66,7
62,2
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,100
0,103
0,116
0,559
0,437
VISCOSITY
CP
0,2
0,2
0,4
0,5
0,8
Z FACTOR
NOTES: (1) Standard conditions: 15°C and 1 atm. (2) There is a case where the heat duty removed in unit 111 for heat exchanger 111-E-0009 is 15 Gcal/h, but does not represent significant variation with respect to Base Case.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
98
DESCRIPTION
RICH AMINE
Rev.
99 REFLUX 011-C-0001
Rev.
TR Project No.: 02020 Page 69 of 193
100 REFLUX 011-C-0002
Rev.
101
Rev.
HVGO TO 011-C-0003
----- TOTAL STREAM ----KG-MOL/HR
355,1
511,0
954,4
1702,0
KG/HR
8122,5
51867,5
96129,3
791931,4
TEMPERATURE
°C
68,2
109,6
64,0
267,2
PRESSURE
BAR(GA)
2,0
3,7
1,0
-0,9
22,9
101,5
100,7
465,3
RATE
MOLECULAR WEIGHT KCAL/KG
-3027,3
-487,1
-508,2
-371,6
KCAL/HR
-2,46E+07
-2,53E+07
-4,89E+07
-2,94E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
KG/HR
-
-
-
-
M3/HR
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
VISCOSITY
CP
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
355,1
511,0
954,4
1702,0
KG/HR
8122,5
51867,5
96129,3
791931,4
M3/HR
8,0
82,6
143,9
1030,4
GAL(US)/MIN
35,1
363,5
633,5
4536,8
M3/HR
MOLECULAR WEIGHT
8,0
72,8
135,6
837,1
22,9
101,5
100,7
465,3 -371,6
ENTHALPY
KCAL/KG
-3027,3
-487,1
-508,2
CP
KCAL/KG-C
0,886
0,614
0,573
0,655
DENSITY
KG/M3
1018,7
628,3
668,1
768,5 0,002
0,002
0,024
0,011
SURFACE TENSION
DYNE/CM
63,2
12,2
15,6
16,9
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,423
0,087
0,095
0,113
VISCOSITY
CP
0,8
0,2
0,3
1,0
Z FACTOR
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
4.
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 70 of 193
DISTILLATION CURVES
For distillation curves (ASTM D86, ASTM D1160) refer to the document Basis of Design, SA-JER-DS011-TRJR320001, appendix 4.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
5.
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 71 of 193
MAXI KEROSENE CASE
The heat and material balance for the Maxi Kerosene Case (Naphtha/Kerosene cut point = 140°C) is included in this section. Stream numbers correspond to the streams identified in the Process Flow Diagrams: SA-JER-DS011-TRJR450007, SA-JER-DS011-TRJR-450026, SA-JER-DS011-TRJR-450008, SA-JER-DS011-TRJR-450009, SA-JERDS011-TRJR-450027, SA-JER-DS011-TRJR-450028 and SA-JER-DS011-TRJR-450040.
5.1.
STREAM COMPOSITIONS – MAXI KEROSENE CASE
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
1
DESCRIPTION
CRUDE
Component
REV: 03 Date: 12-MAY-11
Rev.
2 WILD NAPHTHA
Rev.
3 TOTAL NAPHTHA
Rev.
TR Project No.: 02020 Page 72 of 193
4 KEROSENE TO LP HDS
Rev.
5
Rev.
KEROSENE TO STORAGE
Mass Frac (%)
H2O
0,00
0,00
3,07E-02
0,00
0,00
H2S
0,00
0,450
2,56E-02
0,00
0,00
HYDROGEN
0,00
0,00
0,00
0,00
0,00
AIR
0,00
0,00
0,00
0,00
0,00
METHANE
0,00
4,00E-02
2,28E-03
0,00
0,00 0,00
ETHANE
2,92E-02
0,520
0,260
0,00
ETHYLENE
0,00
0,00
0,00
0,00
0,00
PROPANE
0,441
1,73
3,58
0,00
0,00
PROPENE
0,00
0,00
0,00
0,00
0,00
IBUTANE
0,198
1,31
1,64
0,00
0,00 0,00
BUTANE
0,879
2,81
7,10
0,00
1-BUTENE
0,00
0,00
0,00
0,00
0,00
IPENTANE
0,614
2,48
4,99
0,00
0,00
PENTANE
1,12
2,33
8,95
0,00
0,00
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
0,154
5,59
1,53
0,00
0,00
NBP45*
0,404
3,51
3,39
0,00
0,00
NBP55.*
0,458
3,67
3,82
0,00
0,00
NBP65*
0,546
4,06
4,54
0,00
0,00
NBP75*
0,665
4,72
5,52
2,11E-04
2,11E-04
NBP85*
0,796
5,59
6,60
1,27E-03
1,27E-03
NBP95*
0,900
6,71
7,47
7,08E-03
7,08E-03
NBP105*
1,00
7,95
8,31
3,88E-02
3,88E-02
NBP115*
1,09
9,14
8,91
0,193
0,193
NBP125*
1,16
9,77
8,93
0,788
0,788
NBP135*
1,22
7,59
7,69
2,39
2,39
NBP145*
1,26
5,16
4,92
5,45
5,45
NBP155*
1,29
3,87
1,47
9,18
9,18
NBP165*
1,31
3,15
0,282
10,4
10,4
NBP175*
1,32
2,69
4,17E-02
10,5
10,5
NBP185*
1,32
2,00
3,41E-03
10,1
10,1
NBP195*
1,32
1,21
4,02E-04
9,67
9,67
NBP205*
1,32
0,949
0,00
9,14
9,14
NBP215*
1,34
0,956
0,00
8,48
8,48
NBP225*
1,36
3,54E-02
0,00
7,57
7,57
NBP235*
1,39
0,00
0,00
6,42
6,42
NBP245*
1,42
0,00
0,00
4,83
4,83
NBP255*
1,44
0,00
0,00
3,00
3,00
NBP265*
1,46
0,00
0,00
1,33
1,33
NBP275*
1,48
0,00
0,00
0,421
0,421
NBP285*
1,50
0,00
0,00
7,43E-02
7,43E-02
NBP295*
1,51
0,00
0,00
1,30E-02
1,30E-02
NBP305*
1,52
0,00
0,00
1,98E-03
1,98E-03
NBP315*
1,53
0,00
0,00
2,51E-04
2,51E-04
NBP325*
1,54
0,00
0,00
0,00
0,00
NBP335*
1,55
0,00
0,00
0,00
0,00
NBP345*
1,54
0,00
0,00
0,00
0,00
NBP355*
1,53
0,00
0,00
0,00
0,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 73 of 193
STREAM Nº
1
DESCRIPTION
CRUDE
WILD NAPHTHA
TOTAL NAPHTHA
KEROSENE TO LP HDS
KEROSENE TO STORAGE
NBP365*
1,51
0,00
0,00
0,00
0,00
NBP375*
1,47
0,00
0,00
0,00
0,00
NBP385*
1,43
0,00
0,00
0,00
0,00
NBP395*
1,39
0,00
0,00
0,00
0,00
NBP405*
1,36
0,00
0,00
0,00
0,00
NBP415*
1,33
0,00
0,00
0,00
0,00
NBP425*
1,30
0,00
0,00
0,00
0,00
NBP435*
1,28
0,00
0,00
0,00
0,00
NBP445*
1,27
0,00
0,00
0,00
0,00
NBP455*
1,26
0,00
0,00
0,00
0,00
NBP470*
2,51
0,00
0,00
0,00
0,00
NBP490*
2,73
0,00
0,00
0,00
0,00
NBP510*
2,90
0,00
0,00
0,00
0,00
NBP530*
2,81
0,00
0,00
0,00
0,00
NBP550*
4,22
0,00
0,00
0,00
0,00
NBP570*
1,80
0,00
0,00
0,00
0,00
NBP590*
1,75
0,00
0,00
0,00
0,00
NBP610*
1,67
0,00
0,00
0,00
0,00
NBP630*
1,56
0,00
0,00
0,00
0,00
NBP660*
2,88
0,00
0,00
0,00
0,00
NBP700*
2,66
0,00
0,00
0,00
0,00
NBP740*
2,50
0,00
0,00
0,00
0,00
NBP780*
2,39
0,00
0,00
0,00
0,00
NBP820*
2,27
0,00
0,00
0,00
0,00
NBP860*
2,21
0,00
0,00
0,00
0,00
NBP900*
2,21
0,00
0,00
0,00
0,00
NBP940*
2,21
0,00
0,00
0,00
0,00
NBP980*
2,21
0,00
0,00
0,00
0,00
Component
Rev.
2
Rev.
3
Rev.
4
Rev.
5
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 74 of 193
STREAM Nº
6
DESCRIPTION
LAGO TO LP HDS
LAGO TO STORAGE
HAGO TO HP HDS/ STORAGE
LVGO TO HP HDS/ STORAGE
HVGO TO DHC/MHC
H2O
9,61E-02
9,61E-02
7,62E-02
5,84E-03
2,51E-03
H2S
0,00
0,00
0,00
0,00
0,00
HYDROGEN
0,00
0,00
0,00
0,00
0,00
Component
Rev.
7
Rev.
8+9
Rev.
10+11
Rev.
12
Rev.
Mass Frac (%)
AIR
0,00
0,00
0,00
0,00
0,00
METHANE
0,00
0,00
0,00
0,00
0,00
ETHANE
0,00
0,00
0,00
0,00
0,00
ETHYLENE
0,00
0,00
0,00
0,00
0,00
PROPANE
0,00
0,00
0,00
0,00
0,00
PROPENE
0,00
0,00
0,00
0,00
0,00
IBUTANE
0,00
0,00
0,00
0,00
0,00
BUTANE
0,00
0,00
0,00
0,00
0,00
1-BUTENE
0,00
0,00
0,00
0,00
0,00
IPENTANE
0,00
0,00
0,00
0,00
0,00
PENTANE
2,18E-04
2,18E-04
0,00
1,73E-04
0,00
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
0,00
0,00
0,00
0,00
0,00 0,00
NBP45*
1,74E-04
1,74E-04
0,00
0,00
NBP55.*
3,68E-04
3,68E-04
0,00
0,00
0,00
NBP65*
7,96E-04
7,96E-04
1,01E-04
0,00
0,00
NBP75*
1,71E-03
1,71E-03
2,07E-04
0,00
0,00
NBP85*
3,65E-03
3,65E-03
4,12E-04
0,00
0,00
NBP95*
7,34E-03
7,34E-03
7,75E-04
0,00
0,00
NBP105*
1,45E-02
1,45E-02
1,39E-03
0,00
0,00
NBP115*
2,77E-02
2,77E-02
2,40E-03
3,54E-03
1,99E-04
NBP125*
5,20E-02
5,20E-02
4,02E-03
7,89E-03
3,64E-04
NBP135*
9,49E-02
9,49E-02
6,71E-03
1,54E-02
5,73E-04
NBP145*
0,169
0,169
1,14E-02
2,60E-02
7,75E-04
NBP155*
0,311
0,311
2,02E-02
4,99E-02
1,11E-03
NBP165*
0,494
0,494
3,26E-02
8,26E-02
1,43E-03
NBP175*
0,733
0,733
5,07E-02
0,132
1,80E-03
NBP185*
1,09
1,09
7,84E-02
0,197
1,88E-03
NBP195*
1,54
1,54
0,119
0,274
2,01E-03
NBP205*
2,15
2,15
0,181
0,390
2,28E-03
NBP215*
2,97
2,97
0,273
0,521
2,52E-03
NBP225*
4,05
4,05
0,406
0,621
2,63E-03
NBP235*
5,49
5,49
0,596
0,722
2,86E-03
NBP245*
7,36
7,36
0,859
0,853
3,35E-03
NBP255*
9,42
9,42
1,18
0,906
3,67E-03
NBP265*
11,1
11,1
1,61
0,970
4,24E-03
NBP275*
11,8
11,8
2,15
1,16
5,66E-03
NBP285*
11,3
11,3
3,09
1,62
9,55E-03
NBP295*
10,2
10,2
4,24
2,37
1,69E-02
NBP305*
8,53
8,53
5,85
3,49
3,07E-02
NBP315*
6,10
6,10
8,05
5,18
5,74E-02
NBP325*
3,26
3,26
10,5
7,35
0,105
NBP335*
1,16
1,16
11,9
9,98
0,187
NBP345*
0,293
0,293
11,6
12,7
0,328
NBP355*
6,03E-02
6,03E-02
10,4
15,3
0,585
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 6
STREAM Nº
REV: 03 Date: 12-MAY-11 Rev.
7
Rev.
8+9
Rev.
TR Project No.: 02020 Page 75 of 193 10+11
Rev.
12
LAGO TO LP HDS
LAGO TO STORAGE
HAGO TO HP HDS/ STORAGE
NBP365*
1,09E-02
1,09E-02
8,79
16,2
NBP375*
1,77E-03
1,77E-03
6,92
12,4
2,24
NBP385*
2,54E-04
2,54E-04
4,97
5,03
3,79
DESCRIPTION
Component
LVGO TO HP HDS/ STORAGE
HVGO TO DHC/MHC
1,11
Rev.
Mass Frac (%)
NBP395*
0,00
0,00
3,13
1,13
4,81
NBP405*
0,00
0,00
1,69
0,189
5,26
NBP415*
0,00
0,00
0,772
2,72E-02
5,39
NBP425*
0,00
0,00
0,313
3,55E-03
5,38
NBP435*
0,00
0,00
0,116
4,30E-04
5,32
NBP445*
0,00
0,00
4,01E-02
0,00
5,27
NBP455*
0,00
0,00
1,35E-02
0,00
5,22
NBP470*
0,00
0,00
5,13E-03
0,00
10,4
NBP490*
0,00
0,00
4,94E-04
0,00
11,2
NBP510*
0,00
0,00
0,00
0,00
11,3
NBP530*
0,00
0,00
0,00
0,00
8,83
NBP550*
0,00
0,00
0,00
0,00
9,52
NBP570*
0,00
0,00
0,00
0,00
2,32
NBP590*
0,00
0,00
0,00
0,00
0,942
NBP610*
0,00
0,00
0,00
0,00
0,270
NBP630*
0,00
0,00
0,00
0,00
5,92E-02
NBP660*
0,00
0,00
0,00
0,00
9,81E-03
NBP700*
0,00
0,00
0,00
0,00
3,00E-04
NBP740*
0,00
0,00
0,00
0,00
0,00
NBP780*
0,00
0,00
0,00
0,00
0,00
NBP820*
0,00
0,00
0,00
0,00
0,00
NBP860*
0,00
0,00
0,00
0,00
0,00
NBP900*
0,00
0,00
0,00
0,00
0,00
NBP940*
0,00
0,00
0,00
0,00
0,00
NBP980*
0,00
0,00
0,00
0,00
0,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
13
DESCRIPTION
HVGO TO STORAGE
VAC.RESIDUE TO STORAGE
VAC. RESIDUE TO DCU
Component
Rev.
14
Rev.
15
Rev.
TR Project No.: 02020 Page 76 of 193 16 PREFLASH OVERHEAD
Rev.
17
Rev.
NAPHTHA FROM PREFLASH
Mass Frac (%)
H2O
2,51E-03
2,03E-03
2,03E-03
9,13
11,7
H2S
0,00
0,00
0,00
0,00
0,00
HYDROGEN
0,00
0,00
0,00
0,00
0,00
AIR
0,00
0,00
0,00
0,00
0,00
METHANE
0,00
0,00
0,00
0,00
0,00 0,383
ETHANE
0,00
0,00
0,00
0,244
ETHYLENE
0,00
0,00
0,00
0,00
0,00
PROPANE
0,00
0,00
0,00
3,65
5,64
PROPENE
0,00
0,00
0,00
0,00
0,00
IBUTANE
0,00
0,00
0,00
1,60
2,40
BUTANE
0,00
0,00
0,00
7,04
10,4
1-BUTENE
0,00
0,00
0,00
0,00
0,00
IPENTANE
0,00
0,00
0,00
4,68
6,49 11,5
PENTANE
0,00
0,00
0,00
8,48
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
0,00
0,00
0,00
1,16
1,55 3,89
NBP45*
0,00
0,00
0,00
2,99
NBP55.*
0,00
0,00
0,00
3,32
4,12
NBP65*
0,00
0,00
0,00
3,87
4,53
NBP75*
0,00
0,00
0,00
4,62
5,04
NBP85*
0,00
0,00
0,00
5,42
5,42
NBP95*
0,00
0,00
0,00
6,02
5,43
NBP105*
0,00
0,00
0,00
6,58
5,26
NBP115*
1,99E-04
0,00
0,00
7,01
4,86
NBP125*
3,64E-04
0,00
0,00
7,23
4,27
NBP135*
5,73E-04
0,00
0,00
7,09
3,49
NBP145*
7,75E-04
0,00
0,00
6,11
2,48
NBP155*
1,11E-03
0,00
0,00
2,96
0,931
NBP165*
1,43E-03
0,00
0,00
0,689
0,174
NBP175*
1,80E-03
0,00
0,00
0,102
2,04E-02
NBP185*
1,88E-03
0,00
0,00
7,63E-03
1,10E-03
NBP195*
2,01E-03
0,00
0,00
7,61E-04
0,00
NBP205*
2,28E-03
0,00
0,00
0,00
0,00
NBP215*
2,52E-03
0,00
0,00
0,00
0,00
NBP225*
2,63E-03
0,00
0,00
0,00
0,00
NBP235*
2,86E-03
0,00
0,00
0,00
0,00
NBP245*
3,35E-03
0,00
0,00
0,00
0,00
NBP255*
3,67E-03
0,00
0,00
0,00
0,00
NBP265*
4,24E-03
0,00
0,00
0,00
0,00
NBP275*
5,66E-03
0,00
0,00
0,00
0,00
NBP285*
9,55E-03
0,00
0,00
0,00
0,00
NBP295*
1,69E-02
0,00
0,00
0,00
0,00
NBP305*
3,07E-02
0,00
0,00
0,00
0,00
NBP315*
5,74E-02
0,00
0,00
0,00
0,00
NBP325*
0,105
0,00
0,00
0,00
0,00
NBP335*
0,187
0,00
0,00
0,00
0,00
NBP345*
0,328
0,00
0,00
0,00
0,00
NBP355*
0,585
0,00
0,00
0,00
0,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 77 of 193
STREAM Nº
13
DESCRIPTION
HVGO TO STORAGE
VAC.RESIDUE TO STORAGE
VAC. RESIDUE TO DCU
PREFLASH OVERHEAD
NAPHTHA FROM PREFLASH
NBP365*
1,11
0,00
0,00
0,00
0,00
NBP375*
2,24
0,00
0,00
0,00
0,00
NBP385*
3,79
0,00
0,00
0,00
0,00
NBP395*
4,81
0,00
0,00
0,00
0,00
NBP405*
5,26
1,75E-04
1,75E-04
0,00
0,00
NBP415*
5,39
3,69E-04
3,69E-04
0,00
0,00
NBP425*
5,38
7,62E-04
7,62E-04
0,00
0,00
NBP435*
5,32
1,56E-03
1,56E-03
0,00
0,00
NBP445*
5,27
3,21E-03
3,21E-03
0,00
0,00
NBP455*
5,22
6,61E-03
6,61E-03
0,00
0,00
NBP470*
10,4
3,89E-02
3,89E-02
0,00
0,00
NBP490*
11,2
0,169
0,169
0,00
0,00
NBP510*
11,3
0,620
0,620
0,00
0,00
NBP530*
8,83
2,33
2,33
0,00
0,00
NBP550*
9,52
6,56
6,56
0,00
0,00
NBP570*
2,32
4,22
4,22
0,00
0,00
NBP590*
0,942
5,16
5,16
0,00
0,00
NBP610*
0,270
5,44
5,44
0,00
0,00
NBP630*
5,92E-02
5,24
5,24
0,00
0,00
NBP660*
9,81E-03
9,76
9,76
0,00
0,00
NBP700*
3,00E-04
9,00
9,00
0,00
0,00
NBP740*
0,00
8,47
8,47
0,00
0,00
NBP780*
0,00
8,09
8,09
0,00
0,00
NBP820*
0,00
7,68
7,68
0,00
0,00
NBP860*
0,00
7,49
7,49
0,00
0,00
NBP900*
0,00
7,49
7,49
0,00
0,00
NBP940*
0,00
7,49
7,49
0,00
0,00
NBP980*
0,00
4,72
4,72
0,00
0,00
Component
Rev.
14
Rev.
15
Rev.
16
Rev.
17
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
18
DESCRIPTION
TOPPED CRUDE
Component
REV: 03 Date: 12-MAY-11 Rev.
19
Rev.
20
CDU OVERHEAD
ATM. RESIDUE
Rev.
TR Project No.: 02020 Page 78 of 193 21
Rev.
22
VDU OVERHEAD
RECOVERED OIL
Rev.
Mass Frac (%)
H2O
0,139
12,3
4,43E-02
75,0
2,38E-02
H2S
0,00
4,75E-02
0,00
0,404
2,48E-02
HYDROGEN
0,00
0,00
0,00
5,07E-03
0,00
AIR
0,00
0,00
0,00
0,126
8,72E-04
METHANE
0,00
4,22E-03
0,00
0,179
1,96E-03
ETHANE
2,72E-04
5,86E-02
0,00
0,168
7,50E-03 1,08E-03
ETHYLENE
0,00
0,00
0,00
3,18E-02
PROPANE
1,61E-02
0,402
0,00
0,234
3,18E-02
PROPENE
0,00
0,00
0,00
9,03E-02
1,07E-02
IBUTANE
1,84E-02
0,390
0,00
5,65E-02
1,82E-02
BUTANE
9,72E-02
1,63
0,00
0,271
0,115
1-BUTENE
0,00
0,00
0,00
0,102
3,86E-02
IPENTANE
0,132
2,07
0,00
0,146
0,136
PENTANE
0,263
3,85
0,00
0,231
0,263
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
3,97E-02
1,13
0,00
0,00
0,00
NBP45*
0,118
1,98
0,00
1,61E-04
2,38E-04
NBP55.*
0,157
2,54
0,00
5,34E-02
9,98E-02
NBP65*
0,218
3,40
0,00
4,55E-02
0,105
NBP75*
0,304
4,65
0,00
3,99E-02
0,110
NBP85*
0,413
6,24
0,00
3,33E-02
0,107
NBP95*
0,524
7,85
0,00
2,69E-02
9,73E-02
NBP105*
0,647
9,59
0,00
2,19E-02
8,62E-02
NBP115*
0,772
11,1
0,00
0,624
2,58
NBP125*
0,897
11,8
0,00
1,01
4,30
NBP135*
1,02
10,4
1,21E-04
1,40
6,03
NBP145*
1,14
6,38
1,91E-04
1,65
7,17
NBP155*
1,30
1,69
3,05E-04
2,02
8,79
NBP165*
1,39
0,331
4,51E-04
2,25
9,78
NBP175*
1,41
5,47E-02
6,51E-04
2,39
10,4
NBP185*
1,41
5,11E-03
9,53E-04
2,04
8,88
NBP195*
1,41
6,52E-04
1,41E-03
1,77
7,68
NBP205*
1,42
0,00
2,14E-03
1,56
6,78
NBP215*
1,43
0,00
3,32E-03
1,30
5,63
NBP225*
1,45
0,00
5,25E-03
0,971
4,22
NBP235*
1,48
0,00
8,44E-03
0,720
3,13
NBP245*
1,51
0,00
1,36E-02
0,551
2,40
NBP255*
1,54
0,00
2,08E-02
0,386
1,68
NBP265*
1,57
0,00
3,20E-02
0,275
1,20
NBP275*
1,58
0,00
4,80E-02
0,221
0,962
NBP285*
1,60
0,00
8,28E-02
0,203
0,884
NBP295*
1,62
0,00
0,131
0,200
0,870
NBP305*
1,63
0,00
0,201
0,200
0,871
NBP315*
1,64
0,00
0,298
0,203
0,883
NBP325*
1,65
0,00
0,426
0,197
0,857
NBP335*
1,65
0,00
0,588
0,184
0,799
NBP345*
1,65
0,00
0,778
0,161
0,699
NBP355*
1,64
0,00
0,993
0,132
0,576
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 79 of 193
STREAM Nº
18
DESCRIPTION
TOPPED CRUDE
CDU OVERHEAD
ATM. RESIDUE
VDU OVERHEAD
RECOVERED OIL
NBP365*
1,61
0,00
1,22
9,54E-02
0,415
NBP375*
1,57
0,00
1,47
4,96E-02
0,216
NBP385*
1,53
0,00
1,71
1,36E-02
5,92E-02
NBP395*
1,49
0,00
1,95
2,07E-03
8,98E-03
NBP405*
1,46
0,00
2,12
2,31E-04
1,00E-03
NBP415*
1,42
0,00
2,22
0,00
0,00
NBP425*
1,40
0,00
2,25
0,00
0,00
NBP435*
1,37
0,00
2,24
0,00
0,00
NBP445*
1,36
0,00
2,23
0,00
0,00
NBP455*
1,34
0,00
2,21
0,00
0,00
NBP470*
2,69
0,00
4,43
0,00
0,00
NBP490*
2,92
0,00
4,81
0,00
0,00
NBP510*
3,10
0,00
5,11
0,00
0,00
NBP530*
3,01
0,00
4,95
0,00
0,00
NBP550*
4,52
0,00
7,45
0,00
0,00
NBP570*
1,93
0,00
3,18
0,00
0,00
NBP590*
1,87
0,00
3,08
0,00
0,00
NBP610*
1,79
0,00
2,95
0,00
0,00
NBP630*
1,67
0,00
2,75
0,00
0,00
NBP660*
3,08
0,00
5,08
0,00
0,00
NBP700*
2,84
0,00
4,69
0,00
0,00
NBP740*
2,68
0,00
4,41
0,00
0,00
NBP780*
2,56
0,00
4,21
0,00
0,00
NBP820*
2,42
0,00
4,00
0,00
0,00
NBP860*
2,37
0,00
3,90
0,00
0,00
NBP900*
2,37
0,00
3,90
0,00
0,00
NBP940*
2,37
0,00
3,90
0,00
0,00
NBP980*
2,37
0,00
3,90
0,00
0,00
Component
Rev.
19
Rev.
20
Rev.
21
Rev.
22
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 23
STREAM Nº
OFF GAS
DESCRIPTION
Component
REV: 03 Date: 12-MAY-11 Rev.
24 WASHED OFF GAS
Rev.
25 HAGO+LVGO TO HP HDS
Rev.
TR Project No.: 02020 Page 80 of 193 36 DESALTED CRUDE TO 011-G-0002 A/B
Rev.
51
Rev.
HAGO PA TO 011-G-0012 A/B
Mass Frac (%)
H2O
4,48
4,26
5,78E-02
0,832
H2S
16,0
2,08E-02
1,33E-03
0,00
2,91E-02 0,00
HYDROGEN
0,202
0,293
0,00
0,00
0,00
AIR
5,03
7,32
0,00
0,00
0,00
METHANE
7,13
10,4
1,05E-04
0,00
0,00 0,00
ETHANE
6,65
9,64
4,02E-04
2,90E-02
ETHYLENE
1,26
1,83
0,00
0,00
0,00
PROPANE
9,15
13,1
1,70E-03
0,437
3,84E-04
PROPENE
3,54
5,08
5,71E-04
0,00
0,00
IBUTANE
2,16
3,03
9,71E-04
0,197
6,26E-04 3,48E-03
BUTANE
10,2
14,1
6,14E-03
0,872
1-BUTENE
3,87
5,40
2,06E-03
0,00
0,00
IPENTANE
5,09
6,64
7,27E-03
0,609
6,78E-03 1,40E-02
PENTANE
7,77
9,86
1,40E-02
1,11
DEA
0,00
2,30E-04
0,00
0,00
0,00
NBP38*
0,00
0,00
0,00
0,153
2,24E-03 7,17E-03
NBP45*
5,08E-03
6,15E-03
0,00
0,401
NBP55.*
1,55
1,77
5,36E-03
0,454
1,07E-02
NBP65*
1,18
1,24
5,68E-03
0,541
1,65E-02
NBP75*
0,891
0,843
6,04E-03
0,659
2,56E-02
NBP85*
0,607
0,504
6,02E-03
0,789
3,86E-02
NBP95*
0,373
0,263
5,75E-03
0,893
5,47E-02
NBP105*
0,214
0,124
5,61E-03
0,994
7,50E-02
NBP115*
3,89
1,79
0,140
1,08
9,95E-02
NBP125*
3,65
1,31
0,233
1,15
0,129
NBP135*
2,63
0,715
0,329
1,21
0,163
NBP145*
1,49
0,308
0,395
1,25
0,208
NBP155*
0,635
8,94E-02
0,493
1,28
0,271
NBP165*
0,275
2,83E-02
0,562
1,30
0,331
NBP175*
0,106
0,00
0,617
1,31
0,388
NBP185*
1,92E-02
0,00
0,572
1,31
0,455
NBP195*
4,48E-03
0,00
0,555
1,31
0,535
NBP205*
1,01E-03
0,00
0,578
1,31
0,638
NBP215*
2,07E-04
0,00
0,612
1,33
0,770
NBP225*
0,00
0,00
0,656
1,35
0,943
NBP235*
0,00
0,00
0,759
1,38
1,17
NBP245*
0,00
0,00
0,939
1,40
1,45
NBP255*
0,00
0,00
1,15
1,43
1,78
NBP265*
0,00
0,00
1,45
1,45
2,20
NBP275*
0,00
0,00
1,87
1,47
2,70
NBP285*
0,00
0,00
2,65
1,48
3,55
NBP295*
0,00
0,00
3,65
1,50
4,58
NBP305*
0,00
0,00
5,06
1,51
5,99
NBP315*
0,00
0,00
7,03
1,52
7,90
NBP325*
0,00
0,00
9,27
1,53
9,93
NBP335*
0,00
0,00
10,9
1,53
10,9
NBP345*
0,00
0,00
11,3
1,53
10,5
NBP355*
0,00
0,00
11,0
1,52
9,22
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
23
REV: 03 Date: 12-MAY-11 Rev.
24
Rev.
25
Rev.
TR Project No.: 02020 Page 81 of 193 36 DESALTED CRUDE TO
Rev.
51 HAGO PA TO 011-G-0012 A/B
OFF GAS
WASHED OFF GAS
HAGO+LVGO TO HP HDS
NBP365*
0,00
0,00
9,98
1,49
7,65
NBP375*
0,00
0,00
7,77
1,46
5,95
NBP385*
0,00
0,00
4,72
1,42
4,23
NBP395*
0,00
0,00
2,52
1,38
2,64
NBP405*
0,00
0,00
1,27
1,35
1,41
NBP415*
0,00
0,00
0,566
1,32
0,644
NBP425*
0,00
0,00
0,228
1,29
0,260
NBP435*
0,00
0,00
8,43E-02
1,27
9,60E-02
NBP445*
0,00
0,00
2,91E-02
1,26
3,31E-02
NBP455*
0,00
0,00
9,81E-03
1,24
1,11E-02
NBP470*
0,00
0,00
3,72E-03
2,49
4,21E-03
NBP490*
0,00
0,00
3,58E-04
2,71
4,04E-04
NBP510*
0,00
0,00
0,00
2,87
0,00
NBP530*
0,00
0,00
0,00
2,79
0,00
NBP550*
0,00
0,00
0,00
4,19
0,00
NBP570*
0,00
0,00
0,00
1,79
0,00
NBP590*
0,00
0,00
0,00
1,73
0,00
NBP610*
0,00
0,00
0,00
1,66
0,00
NBP630*
0,00
0,00
0,00
1,55
0,00
NBP660*
0,00
0,00
0,00
2,86
0,00
NBP700*
0,00
0,00
0,00
2,64
0,00
NBP740*
0,00
0,00
0,00
2,48
0,00
NBP780*
0,00
0,00
0,00
2,37
0,00
NBP820*
0,00
0,00
0,00
2,25
0,00
NBP860*
0,00
0,00
0,00
2,19
0,00
NBP900*
0,00
0,00
0,00
2,19
0,00
NBP940*
0,00
0,00
0,00
2,19
0,00
NBP980*
0,00
0,00
0,00
2,19
0,00
DESCRIPTION
Component
011-G-0002 A/B
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
53
REV: 03 Date: 12-MAY-11 Rev.
54
Rev.
59
Rev.
TR Project No.: 02020 Page 82 of 193 61
Rev.
62
HAGO TO 011-C-0006
HAGO TO 011-G-0013 A/B
LAGO PA TO 011-G-0010 A/B
H2O
2,91E-02
7,62E-02
4,55E-02
4,55E-02
9,61E-02
H2S
0,00
0,00
0,00
0,00
0,00
HYDROGEN
0,00
0,00
0,00
0,00
0,00
AIR
0,00
0,00
0,00
0,00
0,00
METHANE
0,00
0,00
0,00
0,00
0,00
ETHANE
0,00
0,00
0,00
0,00
0,00
ETHYLENE
0,00
0,00
0,00
0,00
0,00
PROPANE
3,84E-04
0,00
5,97E-04
5,97E-04
0,00
PROPENE
0,00
0,00
0,00
0,00
0,00
IBUTANE
6,26E-04
0,00
1,04E-03
1,04E-03
0,00
BUTANE
3,48E-03
0,00
5,96E-03
5,96E-03
0,00
DESCRIPTION
Component
LAGO TO 011-C-0005
LAGO TO 011-G-0011 A/B
Rev.
Mass Frac (%)
1-BUTENE
0,00
0,00
0,00
0,00
0,00
IPENTANE
6,78E-03
0,00
1,24E-02
1,24E-02
0,00
PENTANE
1,40E-02
0,00
2,59E-02
2,59E-02
2,18E-04
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
2,24E-03
0,00
4,19E-03
4,19E-03
0,00
NBP45*
7,17E-03
0,00
1,36E-02
1,36E-02
1,74E-04
NBP55.*
1,07E-02
0,00
2,07E-02
2,07E-02
3,68E-04
NBP65*
1,65E-02
1,01E-04
3,26E-02
3,26E-02
7,96E-04
NBP75*
2,56E-02
2,07E-04
5,16E-02
5,16E-02
1,71E-03
NBP85*
3,86E-02
4,12E-04
8,01E-02
8,01E-02
3,65E-03
NBP95*
5,47E-02
7,75E-04
0,117
0,117
7,34E-03
NBP105*
7,50E-02
1,39E-03
0,168
0,168
1,45E-02
NBP115*
9,95E-02
2,40E-03
0,236
0,236
2,77E-02
NBP125*
0,129
4,02E-03
0,325
0,325
5,20E-02
NBP135*
0,163
6,71E-03
0,443
0,443
9,49E-02
NBP145*
0,208
1,14E-02
0,603
0,603
0,169
NBP155*
0,271
2,02E-02
0,853
0,853
0,311
NBP165*
0,331
3,26E-02
1,11
1,11
0,494
NBP175*
0,388
5,07E-02
1,38
1,38
0,733
NBP185*
0,455
7,84E-02
1,75
1,75
1,09
NBP195*
0,535
0,119
2,19
2,19
1,54
NBP205*
0,638
0,181
2,76
2,76
2,15
NBP215*
0,770
0,273
3,50
3,50
2,97
NBP225*
0,943
0,406
4,47
4,47
4,05
NBP235*
1,17
0,596
5,74
5,74
5,49
NBP245*
1,45
0,859
7,36
7,36
7,36
NBP255*
1,78
1,18
9,12
9,12
9,42
NBP265*
2,20
1,61
10,5
10,5
11,1
NBP275*
2,70
2,15
10,9
10,9
11,8
NBP285*
3,55
3,09
10,2
10,2
11,3
NBP295*
4,58
4,24
9,09
9,09
10,2
NBP305*
5,99
5,85
7,48
7,48
8,53
NBP315*
7,90
8,05
5,30
5,30
6,10
NBP325*
9,93
10,5
2,81
2,81
3,26
NBP335*
10,9
11,9
0,994
0,994
1,16
NBP345*
10,5
11,6
0,250
0,250
0,293
NBP355*
9,22
10,4
5,12E-02
5,12E-02
6,03E-02
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
53
REV: 03 Date: 12-MAY-11 Rev.
54
Rev.
59
Rev.
TR Project No.: 02020 Page 83 of 193 61
Rev.
62
HAGO TO 011-C-0006
HAGO TO 011-G-0013 A/B
LAGO PA TO 011-G-0010 A/B
NBP365*
7,65
8,79
9,23E-03
9,23E-03
1,09E-02
NBP375*
5,95
6,92
1,49E-03
1,49E-03
1,77E-03
NBP385*
4,23
4,97
2,14E-04
2,14E-04
2,54E-04
NBP395*
2,64
3,13
0,00
0,00
0,00
NBP405*
1,41
1,69
0,00
0,00
0,00
NBP415*
0,644
0,772
0,00
0,00
0,00
NBP425*
0,260
0,313
0,00
0,00
0,00
NBP435*
9,60E-02
0,116
0,00
0,00
0,00
NBP445*
3,31E-02
4,01E-02
0,00
0,00
0,00
NBP455*
1,11E-02
1,35E-02
0,00
0,00
0,00
NBP470*
4,21E-03
5,13E-03
0,00
0,00
0,00
NBP490*
4,04E-04
4,94E-04
0,00
0,00
0,00
NBP510*
0,00
0,00
0,00
0,00
0,00
NBP530*
0,00
0,00
0,00
0,00
0,00
NBP550*
0,00
0,00
0,00
0,00
0,00
NBP570*
0,00
0,00
0,00
0,00
0,00
NBP590*
0,00
0,00
0,00
0,00
0,00
NBP610*
0,00
0,00
0,00
0,00
0,00
NBP630*
0,00
0,00
0,00
0,00
0,00
NBP660*
0,00
0,00
0,00
0,00
0,00
NBP700*
0,00
0,00
0,00
0,00
0,00
NBP740*
0,00
0,00
0,00
0,00
0,00
NBP780*
0,00
0,00
0,00
0,00
0,00
NBP820*
0,00
0,00
0,00
0,00
0,00
NBP860*
0,00
0,00
0,00
0,00
0,00
NBP900*
0,00
0,00
0,00
0,00
0,00
NBP940*
0,00
0,00
0,00
0,00
0,00
NBP980*
0,00
0,00
0,00
0,00
0,00
DESCRIPTION
Component
LAGO TO 011-C-0005
LAGO TO 011-G-0011 A/B
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
67 KERO PA TO
DESCRIPTION
Component
011-G-0008 A/B
REV: 03 Date: 12-MAY-11 Rev.
69
Rev.
KERO TO 011-C-0005
70 KERO TO 011-G-0009 A/B
Rev.
TR Project No.: 02020 Page 84 of 193 75
77 (1)
NAPHTHA TO 011-E-0021
ATM. RESIDUE TO 011-C-0003
Rev.
Mass Frac (%)
H2O
8,52E-02
8,52E-02
0,00
6,53
1,23
H2S
0,00
0,00
0,00
2,40E-02
2,06E-02
HYDROGEN
0,00
0,00
0,00
0,00
2,58E-04
AIR
0,00
0,00
0,00
0,00
6,44E-03
METHANE
0,00
0,00
0,00
2,13E-03
9,13E-03 8,56E-03
ETHANE
0,00
0,00
0,00
0,243
ETHYLENE
0,00
0,00
0,00
0,00
1,62E-03
PROPANE
1,36E-03
1,36E-03
0,00
3,35
1,19E-02
PROPENE
0,00
0,00
0,00
0,00
4,60E-03
IBUTANE
2,67E-03
2,67E-03
0,00
1,53
2,88E-03 1,38E-02
BUTANE
1,53E-02
1,53E-02
0,00
6,64
1-BUTENE
0,00
0,00
0,00
0,00
5,21E-03
IPENTANE
3,60E-02
3,60E-02
0,00
4,66
7,44E-03
PENTANE
7,77E-02
7,77E-02
0,00
8,36
1,18E-02
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
1,64E-02
1,64E-02
0,00
1,43
0,00
NBP45*
4,62E-02
4,62E-02
0,00
3,17
0,00
NBP55.*
7,54E-02
7,54E-02
0,00
3,57
2,72E-03
NBP65*
0,129
0,129
0,00
4,24
2,32E-03
NBP75*
0,225
0,225
2,11E-04
5,16
2,04E-03
NBP85*
0,388
0,388
1,27E-03
6,17
1,70E-03
NBP95*
0,632
0,632
7,08E-03
6,99
1,37E-03
NBP105*
1,02
1,02
3,88E-02
7,77
1,12E-03
NBP115*
1,65
1,65
0,193
8,33
3,20E-02
NBP125*
2,69
2,69
0,788
8,35
5,20E-02
NBP135*
4,49
4,49
2,39
7,19
7,22E-02
NBP145*
7,33
7,33
5,45
4,60
8,57E-02
NBP155*
10,1
10,1
9,18
1,37
0,106
NBP165*
10,4
10,4
10,4
0,264
0,119
NBP175*
9,80
9,80
10,5
3,90E-02
0,129
NBP185*
8,99
8,99
10,1
3,19E-03
0,114
NBP195*
8,29
8,29
9,67
3,76E-04
0,104
NBP205*
7,64
7,64
9,14
0,00
9,93E-02
NBP215*
6,96
6,96
8,48
0,00
9,23E-02
NBP225*
6,12
6,12
7,57
0,00
8,08E-02
NBP235*
5,13
5,13
6,42
0,00
7,30E-02
NBP245*
3,83
3,83
4,83
0,00
7,10E-02
NBP255*
2,36
2,36
3,00
0,00
6,53E-02
NBP265*
1,05
1,05
1,33
0,00
6,30E-02
NBP275*
0,329
0,329
0,421
0,00
7,03E-02
NBP285*
5,79E-02
5,79E-02
7,43E-02
0,00
9,34E-02
NBP295*
1,01E-02
1,01E-02
1,30E-02
0,00
0,133
NBP305*
1,54E-03
1,54E-03
1,98E-03
0,00
0,193
NBP315*
1,95E-04
1,95E-04
2,51E-04
0,00
0,287
NBP325*
0,00
0,00
0,00
0,00
0,411
NBP335*
0,00
0,00
0,00
0,00
0,573
NBP345*
0,00
0,00
0,00
0,00
0,765
NBP355*
0,00
0,00
0,00
0,00
0,997
NOTES: (1) Cracking in the vacuum heater has been considered.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
67 KERO PA TO
DESCRIPTION
Component
011-G-0008 A/B
REV: 03 Date: 12-MAY-11 Rev.
69 KERO TO 011-C-0005
Rev.
70
75
77 (1)
011-G-0009 A/B
NAPHTHA TO 011-E-0021
ATM. RESIDUE TO 011-C-0003
KERO TO
Rev.
TR Project No.: 02020 Page 85 of 193 Rev.
Mass Frac (%)
NBP365*
0,00
0,00
0,00
0,00
1,26
NBP375*
0,00
0,00
0,00
0,00
1,54
NBP385*
0,00
0,00
0,00
0,00
1,82
NBP395*
0,00
0,00
0,00
0,00
2,06
NBP405*
0,00
0,00
0,00
0,00
2,20
NBP415*
0,00
0,00
0,00
0,00
2,24
NBP425*
0,00
0,00
0,00
0,00
2,24
NBP435*
0,00
0,00
0,00
0,00
2,21
NBP445*
0,00
0,00
0,00
0,00
2,19
NBP455*
0,00
0,00
0,00
0,00
2,17
NBP470*
0,00
0,00
0,00
0,00
4,35
NBP490*
0,00
0,00
0,00
0,00
4,73
NBP510*
0,00
0,00
0,00
0,00
5,02
NBP530*
0,00
0,00
0,00
0,00
4,87
NBP550*
0,00
0,00
0,00
0,00
7,31
NBP570*
0,00
0,00
0,00
0,00
3,12
NBP590*
0,00
0,00
0,00
0,00
3,02
NBP610*
0,00
0,00
0,00
0,00
2,89
NBP630*
0,00
0,00
0,00
0,00
2,70
NBP660*
0,00
0,00
0,00
0,00
4,98
NBP700*
0,00
0,00
0,00
0,00
4,59
NBP740*
0,00
0,00
0,00
0,00
4,33
NBP780*
0,00
0,00
0,00
0,00
4,13
NBP820*
0,00
0,00
0,00
0,00
3,92
NBP860*
0,00
0,00
0,00
0,00
3,82
NBP900*
0,00
0,00
0,00
0,00
3,82
NBP940*
0,00
0,00
0,00
0,00
3,82
NBP980*
0,00
0,00
0,00
0,00
2,41
NOTES: (1) Cracking in the vacuum heater has been considered.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 78
STREAM Nº
VAC. RESIDUE
TO 011-G-0018 A/B
DESCRIPTION
Component
REV: 03 Date: 12-MAY-11 81
Rev.
TR Project No.: 02020 Page 86 of 193
84
85
87
HVGO TO 011-G-0017 A/B
MVGO TO 011-G-0016 A/B
MVGO + HVGO TO 011-E-0015 A/B
Rev.
LVGO TO 011-G-0015 A/B
5,84E-03
Mass Frac (%)
H2O
#¡VALOR!
2,14E-03
3,16E-03
2,51E-03
H2S
2,03E-03
0,00
0,00
0,00
0,00
HYDROGEN
0,00
0,00
0,00
0,00
0,00
AIR
0,00
0,00
0,00
0,00
0,00
METHANE
0,00
0,00
0,00
0,00
0,00 0,00
ETHANE
0,00
0,00
0,00
0,00
ETHYLENE
0,00
0,00
0,00
0,00
0,00
PROPANE
0,00
0,00
0,00
0,00
0,00
PROPENE
0,00
0,00
0,00
0,00
0,00
IBUTANE
0,00
0,00
0,00
0,00
0,00
BUTANE
0,00
0,00
0,00
0,00
0,00
1-BUTENE
0,00
0,00
0,00
0,00
0,00
IPENTANE
0,00
0,00
0,00
0,00
0,00
PENTANE
0,00
0,00
0,00
0,00
1,73E-04
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
0,00
0,00
0,00
0,00
0,00
NBP45*
0,00
0,00
0,00
0,00
0,00
NBP55.*
0,00
0,00
0,00
0,00
0,00
NBP65*
0,00
0,00
0,00
0,00
0,00
NBP75*
0,00
0,00
0,00
0,00
0,00
NBP85*
0,00
0,00
0,00
0,00
0,00
NBP95*
0,00
0,00
0,00
0,00
0,00
NBP105*
0,00
0,00
0,00
0,00
0,00
NBP115*
0,00
1,44E-04
2,96E-04
1,99E-04
3,54E-03
NBP125*
0,00
2,58E-04
5,52E-04
3,64E-04
7,89E-03
NBP135*
0,00
3,96E-04
8,87E-04
5,73E-04
1,54E-02
NBP145*
0,00
5,21E-04
1,23E-03
7,75E-04
2,60E-02
NBP155*
0,00
7,20E-04
1,79E-03
1,11E-03
4,99E-02
NBP165*
0,00
9,12E-04
2,36E-03
1,43E-03
8,26E-02
NBP175*
0,00
1,12E-03
3,01E-03
1,80E-03
0,132
NBP185*
0,00
1,14E-03
3,20E-03
1,88E-03
0,197
NBP195*
0,00
1,19E-03
3,49E-03
2,01E-03
0,274
NBP205*
0,00
1,31E-03
4,00E-03
2,28E-03
0,390
NBP215*
0,00
1,41E-03
4,49E-03
2,52E-03
0,521
NBP225*
0,00
1,44E-03
4,75E-03
2,63E-03
0,621
NBP235*
0,00
1,53E-03
5,22E-03
2,86E-03
0,722
NBP245*
0,00
1,75E-03
6,18E-03
3,35E-03
0,853
NBP255*
0,00
1,88E-03
6,85E-03
3,67E-03
0,906
NBP265*
0,00
2,12E-03
7,99E-03
4,24E-03
0,970
NBP275*
0,00
2,78E-03
1,08E-02
5,66E-03
1,16
NBP285*
0,00
4,60E-03
1,84E-02
9,55E-03
1,62
NBP295*
0,00
7,97E-03
3,27E-02
1,69E-02
2,37
NBP305*
0,00
1,43E-02
6,00E-02
3,07E-02
3,49
NBP315*
0,00
2,62E-02
0,113
5,74E-02
5,18
NBP325*
0,00
4,69E-02
0,207
0,105
7,35
NBP335*
0,00
8,19E-02
0,374
0,187
9,98
NBP345*
0,00
0,139
0,664
0,328
12,7
NBP355*
0,00
0,231
1,21
0,585
15,3
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
78 VAC. RESIDUE
TO 011-G-0018 A/B
DESCRIPTION
Component
REV: 03 Date: 12-MAY-11 81
Rev.
TR Project No.: 02020 Page 87 of 193
84
85
87
HVGO TO 011-G-0017 A/B
MVGO TO 011-G-0016 A/B
MVGO + HVGO TO 011-E-0015 A/B
Rev.
LVGO TO 011-G-0015 A/B
Mass Frac (%)
NBP365*
0,00
0,376
2,41
1,11
16,2
NBP375*
0,00
0,609
5,14
2,24
12,4
NBP385*
0,00
0,963
8,82
3,79
5,03
NBP395*
0,00
1,42
10,8
4,81
1,13
NBP405*
1,75E-04
1,95
11,2
5,26
0,189
NBP415*
3,69E-04
2,51
10,5
5,39
2,72E-02
NBP425*
7,62E-04
3,10
9,45
5,38
3,55E-03
NBP435*
1,56E-03
3,70
8,19
5,32
4,30E-04
NBP445*
3,21E-03
4,33
6,94
5,27
0,00
NBP455*
6,61E-03
4,94
5,72
5,22
0,00
NBP470*
3,89E-02
11,6
8,28
10,4
0,00
NBP490*
0,169
14,4
5,35
11,2
0,00
NBP510*
0,620
16,0
3,05
11,3
0,00
NBP530*
2,33
13,3
0,813
8,83
0,00
NBP550*
6,56
14,6
0,473
9,52
0,00
NBP570*
4,22
3,59
6,18E-02
2,32
0,00
NBP590*
5,16
1,46
1,34E-02
0,942
0,00
NBP610*
5,44
0,420
2,03E-03
0,270
0,00
NBP630*
5,24
9,24E-02
2,33E-04
5,92E-02
0,00
NBP660*
9,76
1,53E-02
0,00
9,81E-03
0,00
NBP700*
9,00
4,69E-04
0,00
3,00E-04
0,00
NBP740*
8,47
0,00
0,00
0,00
0,00
NBP780*
8,09
0,00
0,00
0,00
0,00
NBP820*
7,68
0,00
0,00
0,00
0,00
NBP860*
7,49
0,00
0,00
0,00
0,00
NBP900*
7,49
0,00
0,00
0,00
0,00
NBP940*
7,49
0,00
0,00
0,00
0,00
NBP980*
0,00
0,00
0,00
0,00
0,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
90
91 (1)
DESCRIPTION
OFF GAS TO 011-C-0007
BRINE TO WWT
SOUR WATER TO SWS
Component
Rev.
96 (2)
Rev.
TR Project No.: 02020 Page 88 of 193 97 LEAN AMINE
Rev.
98
Rev.
RICH AMINE
Mass Frac (%)
H2O
1,28
100,0
100,0
74,9
73,5
H2S
19,2
0,00
0,00
0,162
1,86
HYDROGEN
0,244
0,00
0,00
0,00
0,00
AIR
6,08
0,00
0,00
0,00
3,34E-04
METHANE
8,62
0,00
0,00
0,00
9,64E-04
ETHANE
8,01
0,00
0,00
0,00
1,11E-03
ETHYLENE
1,52
0,00
0,00
0,00
4,80E-04
PROPANE
10,9
0,00
0,00
0,00
1,24E-03
PROPENE
4,23
0,00
0,00
0,00
1,39E-03
IBUTANE
2,52
0,00
0,00
0,00
1,93E-04
BUTANE
11,8
0,00
0,00
0,00
1,29E-03
1-BUTENE
4,49
0,00
0,00
0,00
1,10E-03
IPENTANE
5,52
0,00
0,00
0,00
3,01E-04
PENTANE
8,19
0,00
0,00
0,00
5,81E-04
DEA
0,00
0,00
0,00
25,0
24,6
NBP38*
0,00
0,00
0,00
0,00
0,00 0,00
NBP45*
5,10E-03
0,00
0,00
0,00
NBP55.*
1,47
0,00
0,00
0,00
0,00
NBP65*
1,03
0,00
0,00
0,00
0,00
NBP75*
0,700
0,00
0,00
0,00
0,00
NBP85*
0,419
0,00
0,00
0,00
0,00
NBP95*
0,218
0,00
0,00
0,00
0,00
NBP105*
0,103
0,00
0,00
0,00
0,00
NBP115*
1,49
0,00
0,00
0,00
0,00
NBP125*
1,09
0,00
0,00
0,00
0,00
NBP135*
0,594
0,00
0,00
0,00
0,00
NBP145*
0,255
0,00
0,00
0,00
0,00
NBP155*
7,42E-02
0,00
0,00
0,00
0,00
NBP165*
2,35E-02
0,00
0,00
0,00
0,00
NBP175*
6,59E-03
0,00
0,00
0,00
0,00
NBP185*
7,49E-04
0,00
0,00
0,00
0,00
NBP195*
1,21E-04
0,00
0,00
0,00
0,00
NBP205*
0,00
0,00
0,00
0,00
0,00
NBP215*
0,00
0,00
0,00
0,00
0,00
NBP225*
0,00
0,00
0,00
0,00
0,00
NBP235*
0,00
0,00
0,00
0,00
0,00
NBP245*
0,00
0,00
0,00
0,00
0,00
NBP255*
0,00
0,00
0,00
0,00
0,00
NBP265*
0,00
0,00
0,00
0,00
0,00
NBP275*
0,00
0,00
0,00
0,00
0,00
NBP285*
0,00
0,00
0,00
0,00
0,00
NBP295*
0,00
0,00
0,00
0,00
0,00
NBP305*
0,00
0,00
0,00
0,00
0,00
NBP315*
0,00
0,00
0,00
0,00
0,00
NBP325*
0,00
0,00
0,00
0,00
0,00
NBP335*
0,00
0,00
0,00
0,00
0,00
NBP345*
0,00
0,00
0,00
0,00
0,00
NBP355*
0,00
0,00
0,00
0,00
0,00
NOTES: (1) For details of the dissolved species on this stream refer to pertinent vendor document. (2) This stream may contain up to 60 pmm of H2S.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 89 of 193
STREAM Nº
90
91 (1)
DESCRIPTION
OFF GAS TO 011-C-0007
BRINE TO WWT
SOUR WATER TO SWS
LEAN AMINE
RICH AMINE
NBP365*
0,00
0,00
0,00
0,00
0,00
NBP375*
0,00
0,00
0,00
0,00
0,00
NBP385*
0,00
0,00
0,00
0,00
0,00
NBP395*
0,00
0,00
0,00
0,00
0,00
NBP405*
0,00
0,00
0,00
0,00
0,00
NBP415*
0,00
0,00
0,00
0,00
0,00
NBP425*
0,00
0,00
0,00
0,00
0,00
NBP435*
0,00
0,00
0,00
0,00
0,00
NBP445*
0,00
0,00
0,00
0,00
0,00
NBP455*
0,00
0,00
0,00
0,00
0,00
NBP470*
0,00
0,00
0,00
0,00
0,00
NBP490*
0,00
0,00
0,00
0,00
0,00
NBP510*
0,00
0,00
0,00
0,00
0,00
NBP530*
0,00
0,00
0,00
0,00
0,00
NBP550*
0,00
0,00
0,00
0,00
0,00
NBP570*
0,00
0,00
0,00
0,00
0,00
NBP590*
0,00
0,00
0,00
0,00
0,00
NBP610*
0,00
0,00
0,00
0,00
0,00
NBP630*
0,00
0,00
0,00
0,00
0,00
NBP660*
0,00
0,00
0,00
0,00
0,00
NBP700*
0,00
0,00
0,00
0,00
0,00
NBP740*
0,00
0,00
0,00
0,00
0,00
NBP780*
0,00
0,00
0,00
0,00
0,00
NBP820*
0,00
0,00
0,00
0,00
0,00
NBP860*
0,00
0,00
0,00
0,00
0,00
NBP900*
0,00
0,00
0,00
0,00
0,00
NBP940*
0,00
0,00
0,00
0,00
0,00
NBP980*
0,00
0,00
0,00
0,00
0,00
Component
Rev.
96 (2)
Rev.
97
Rev.
98
Rev.
Mass Frac (%)
NOTES: (1) For details of the dissolved species on this stream refer to pertinent vendor document. (2) This stream may contain up to 60 pmm of H2S.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
99
DESCRIPTION
REFLUX 011-C-0001
REFLUX 011-C-0002
H2O
0,260
4,69E-02
H2S
0,00
5,42E-02
HYDROGEN
0,00
0,00
AIR
0,00
0,00
Component
Rev.
100
TR Project No.: 02020 Page 90 of 193
Rev.
Mass Frac (%)
METHANE
0,00
4,81E-03
ETHANE
1,08E-02
6,68E-02
ETHYLENE
0,00
0,00
PROPANE
0,350
0,459
PROPENE
0,00
0,00
IBUTANE
0,275
0,444 1,85
BUTANE
1,44
1-BUTENE
0,00
0,00
IPENTANE
1,73
2,36
PENTANE
3,55
4,39
DEA
0,00
0,00
NBP38*
0,524
1,29
NBP45*
1,55
2,26
NBP55.*
2,07
2,89
NBP65*
2,90
3,88
NBP75*
4,11
5,31
NBP85*
5,68
7,11
NBP95*
7,34
8,95
NBP105*
9,22
10,9
NBP115*
11,1
12,7
NBP125*
12,8
13,5
NBP135*
13,8
11,9
NBP145*
12,8
7,28
NBP155*
6,67
1,93
NBP165*
1,63
0,377
NBP175*
0,251
6,24E-02
NBP185*
1,95E-02
5,82E-03
NBP195*
1,99E-03
7,44E-04
NBP205*
1,96E-04
0,00
NBP215*
0,00
0,00
NBP225*
0,00
0,00
NBP235*
0,00
0,00
NBP245*
0,00
0,00
NBP255*
0,00
0,00
NBP265*
0,00
0,00
NBP275*
0,00
0,00
NBP285*
0,00
0,00
NBP295*
0,00
0,00
NBP305*
0,00
0,00
NBP315*
0,00
0,00
NBP325*
0,00
0,00
NBP335*
0,00
0,00
NBP345*
0,00
0,00
NBP355*
0,00
0,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
99
DESCRIPTION
REFLUX 011-C-0001
REFLUX 011-C-0002
NBP365*
0,00
0,00
NBP375*
0,00
0,00
NBP385*
0,00
0,00
NBP395*
0,00
0,00
NBP405*
0,00
0,00
NBP415*
0,00
0,00
NBP425*
0,00
0,00
NBP435*
0,00
0,00
NBP445*
0,00
0,00
NBP455*
0,00
0,00
NBP470*
0,00
0,00
NBP490*
0,00
0,00
NBP510*
0,00
0,00
NBP530*
0,00
0,00
NBP550*
0,00
0,00
NBP570*
0,00
0,00
NBP590*
0,00
0,00
NBP610*
0,00
0,00
NBP630*
0,00
0,00
NBP660*
0,00
0,00
NBP700*
0,00
0,00
NBP740*
0,00
0,00
NBP780*
0,00
0,00
NBP820*
0,00
0,00
NBP860*
0,00
0,00
NBP900*
0,00
0,00
NBP940*
0,00
0,00
NBP980*
0,00
0,00
Component
Rev.
100
TR Project No.: 02020 Page 91 of 193
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
5.2.
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 92 of 193
PHYSICAL PROPERTIES – MAXI KEROSENE CASE STREAM Nº
1
DESCRIPTION
CRUDE
Rev.
2 WILD NAPHTHA
Rev.
3 TOTAL NAPHTHA
Rev.
4 KEROSENE TO LP HDS
Rev.
5
Rev.
KEROSENE TO STORAGE
----- TOTAL STREAM ----KG-MOL/HR
4743,9
90,5
1748,1
828,0
92,1
KG/HR
1179247,0
8500,0
149398,1
126800,0
14101,8
TEMPERATURE
°C
38,9
70,0
43,3
66,4
43,1
PRESSURE
BAR(GA)
2,0
5,0
7,0
7,0
7,0
248,6
93,9
85,5
153,1
153,1
RATE
MOLECULAR WEIGHT KCAL/KG
-503,4
-506,4
-534,7
-498,3
-510,5
KCAL/HR
-5,94E+08
-4,30E+06
-7,99E+07
-6,32E+07
-7,20E+06
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
4743,9
90,5
1748,1
828,0
92,1
KG/HR
1179247,0
8500,0
149398,1
126800,0
14101,8
M3/HR
1347,9
13,1
229,0
170,1
18,5
GAL(US)/MIN
5934,4
57,6
1008,1
749,0
81,3
M3/HR
1330,8
12,2
222,2
161,8
18,0
248,6
93,9
85,5
153,1
153,1
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-503,4
-506,4
-534,7
-498,3
-510,5
CP
KCAL/KG-C
0,457
0,582
0,566
0,538
0,513
DENSITY
KG/M3
874,9
649,9
652,5
745,4
763,5
0,033
0,030
0,040
0,058
0,061
Z FACTOR SURFACE TENSION
DYNE/CM
22,9
13,5
14,8
20,6
22,6
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,117
0,088
0,091
0,112
0,116
VISCOSITY
CP
9,3
0,3
0,3
0,7
0,9
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
6
DESCRIPTION
LAGO TO LP HDS
Rev.
7 LAGO TO STORAGE
Rev.
TR Project No.: 02020 Page 93 of 193
8+9 HAGO TO HP HDS/ STORAGE
Rev.
10+11 LVGO TO HP HDS/ STORAGE
Rev.
12
Rev.
HVGO TO DHC/MHC
----- TOTAL STREAM ----KG-MOL/HR
527,0
58,6
412,6
122,5
602,7
KG/HR
108303,5
12034,0
108875,4
33200,1
255165,0
TEMPERATURE
°C
50,2
50,2
50,0
50,0
163,3
PRESSURE
BAR(GA)
7,0
7,0
7,5
7,5
13,3
205,5
205,5
263,9
271,0
423,4
RATE
MOLECULAR WEIGHT KCAL/KG
-506,8
-506,8
-502,5
-499,9
-435,5
KCAL/HR
-5,49E+07
-6,10E+06
-5,47E+07
-1,66E+07
-1,11E+08
MOLE FRACTION LIQUID
0,991
0,991
0,991
1,000
1,000
MOLE FRACTION FREE WATER
0,009
0,009
0,009
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
527,0
58,6
412,6
122,5
602,7
KG/HR
108303,5
12034,0
108875,4
33200,1
255165,0
M3/HR
133,9
14,9
127,5
38,7
306,3
GAL(US)/MIN
589,5
65,5
561,3
170,4
1348,6
M3/HR
130,1
14,5
124,2
37,7
272,5
205,5
205,5
263,9
271,0
423,4
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-506,8
-506,8
-502,5
-499,9
-435,5
CP
KCAL/KG-C
0,494
0,494
0,466
0,464
0,566
DENSITY
KG/M3
808,9
808,9
854,0
857,7
833,0
-
-
-
0,100
0,200
Z FACTOR SURFACE TENSION
DYNE/CM
-
-
-
27,4
22,1
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,125
0,125
0,133
0,133
0,126
VISCOSITY
CP
2,2
2,2
5,9
6,2
3,4
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
13
DESCRIPTION
HVGO TO STORAGE
Rev.
14 VAC.RESIDUE TO STORAGE
Rev.
TR Project No.: 02020 Page 94 of 193
15 VAC. RESIDUE TO DCU
Rev.
16 PREFLASH OVERHEAD
Rev.
17
Rev.
NAPHTHA FROM PREFLASH
----- TOTAL STREAM ----KG-MOL/HR
67,0
40,4
364,1
2236,1
1602,9
KG/HR
28352,1
34745,3
313205,9
142333,2
89126,9
TEMPERATURE
°C
90,0
180,0
200,0
138,3
110,2
PRESSURE
BAR(GA)
7,0
7,0
10,2
3,7
3,0
423,4
860,3
860,3
63,7
55,6
RATE
MOLECULAR WEIGHT KCAL/KG
-474,4
-424,1
-413,0
-661,4
-754,4
KCAL/HR
-1,34E+07
-1,47E+07
-1,29E+08
-9,41E+07
-6,72E+07
MOLE FRACTION LIQUID
1,000
1,000
1,000
0,000
0,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
2236,1
1602,9
KG/HR
-
-
-
142333,2
89126,9
M3/HR
-
-
-
15094,9
11986,4
M3/HR
-
-
-
52870,5
37898,9
-
-
-
63,7
55,6
-
-661,4
-754,4 0,514
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
CP
KCAL/KG-C
-
-
-
0,535
DENSITY
KG/M3
-
-
-
9,43
7,44
-
-
-
0,928
0,939
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
0,021
0,020
VISCOSITY
CP
-
-
-
0,01
0,01
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
67,0
40,4
364,1
-
-
KG/HR
28352,1
34745,3
313205,9
-
-
M3/HR
32,1
36,3
331,5
-
-
GAL(US)/MIN
141,5
159,7
1459,7
-
-
M3/HR
MOLECULAR WEIGHT
30,3
33,0
297,4
-
-
423,4
860,3
860,3
-
-
ENTHALPY
KCAL/KG
-474,4
-424,1
-413,0
-
-
CP
KCAL/KG-C
0,489
0,545
0,564
-
-
DENSITY
KG/M3
882,1
957,9
944,7
-
-
0,127
0,191
0,260
-
-
Z FACTOR SURFACE TENSION
DYNE/CM
26,5
24,8
23,9
-
-
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,137
0,144
0,142
-
-
VISCOSITY
CP
12,3
37,2
24,0
-
-
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
18
DESCRIPTION
TOPPED CRUDE
Rev.
19 CDU OVERHEAD
Rev.
TR Project No.: 02020 Page 95 of 193
20 ATM. RESIDUE
Rev.
21 VDU OVERHEAD
Rev.
22
Rev.
RECOVERED OIL
----- TOTAL STREAM ----KG-MOL/HR
3804,0
3314,9
1198,2
1516,7
54,3
KG/HR
1102062,9
209977,7
668774,8
34684,1
7976,3
TEMPERATURE
°C
186,9
114,0
351,2
83,2
50,3
PRESSURE
BAR(GA)
3,9
1,0
14,9
-0,9
7,5
289,7
63,3
558,2
22,9
146,9
RATE
MOLECULAR WEIGHT KCAL/KG
-426,8
-745,6
-317,1
-2478,6
-507,5
KCAL/HR
-4,70E+08
-1,57E+08
-2,12E+08
-8,60E+07
-4,05E+06
MOLE FRACTION LIQUID
1,000
0,000
1,000
0,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1)
KG-MOL/HR
-
3314,9
-
1516,7
-
KG/HR
-
209977,7
-
34684,1
-
M3/HR
-
51188,6
-
395859,4
-
M3/HR
-
78379,0
-
35862,2
-
-
63,3
-
22,9
-
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-745,6
-
-2478,6
-
CP
KCAL/KG-C
-
0,499
-
0,445
-
DENSITY
KG/M3
-
4,10
-
0,09
-
-
0,959
-
0,998
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
0,018
-
0,019
-
VISCOSITY
CP
-
0,01
-
0,01
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
3804,0
-
1198,2
-
54,3
KG/HR
1102062,9
-
668774,8
-
7976,3
M3/HR
1407,4
-
874,3
-
10,6
GAL(US)/MIN
6196,5
-
3849,6
-
46,6
M3/HR
1210,7
-
672,7
-
10,3
289,7
-
558,2
-
146,9
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-426,8
-
-317,1
-
-507,5
CP
KCAL/KG-C
0,599
-
0,701
-
0,524
DENSITY
KG/M3
783,1
-
764,9
-
753,2
0,047
-
0,224
-
0,062
Z FACTOR SURFACE TENSION
DYNE/CM
15,4
-
13,0
-
21,4
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,102
-
0,105
-
0,113
VISCOSITY
CP
1,3
-
0,9
-
0,8
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
23
DESCRIPTION
OFF GAS
Rev.
24 WASHED OFF GAS
Rev.
TR Project No.: 02020 Page 96 of 193
25 HAGO+LVGO TO HP HDS
Rev.
26 HAGO+LVGO TO STORAGE
Rev.
27
Rev.
FRESH CRUDE TO 011-E-0002
----- TOTAL STREAM ----KG-MOL/HR
22,8
16,8
555,8
33,6
4743,9
KG/HR
871,5
599,0
141500,0
8551,8
1179247,0
TEMPERATURE
°C
50,0
65,0
50,0
50,0
51,9
PRESSURE
BAR(GA)
0,3
1,8
7,5
7,0
26,2
38,2
35,7
254,6
254,6
248,6
RATE
MOLECULAR WEIGHT KCAL/KG
-527,8
-568,8
-502,2
-502,2
-496,9
KCAL/HR
-4,60E+05
-3,41E+05
-7,11E+07
-4,29E+06
-5,86E+08
MOLE FRACTION LIQUID
0,000
0,000
0,994
0,994
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,006
0,006
0,000
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1)
KG-MOL/HR
22,8
16,8
-
-
-
KG/HR
871,5
599,0
-
-
-
M3/HR
466,8
164,6
-
-
-
M3/HR
539,4
396,7
-
-
-
38,2
35,7
-
-
-
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-527,8
-568,8
-
-
-
CP
KCAL/KG-C
0,404
0,449
-
-
-
DENSITY
KG/M3
1,87
3,64
-
-
-
0,990
0,982
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,021
0,025
-
-
-
VISCOSITY
CP
0,01
0,01
-
-
-
KG-MOL/HR
-
-
555,8
33,6
4743,9
KG/HR
-
-
141500,0
8551,8
1179247,0
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
M3/HR
-
-
166,6
10,1
1359,7
GAL(US)/MIN
-
-
733,5
44,3
5986,5
M3/HR
-
-
162,4
9,8
1330,8
-
-
254,6
254,6
248,6
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-502,2
-502,2
-496,9
CP
KCAL/KG-C
-
-
0,469
0,469
0,471
DENSITY
KG/M3
-
-
849,4
849,3
867,3
-
-
-
-
0,289
Z FACTOR SURFACE TENSION
DYNE/CM
-
-
-
-
21,8
THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
0,131
0,131
0,115
VISCOSITY
CP
-
-
5,3
5,3
7,4
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
REV: 03 Date: 12-MAY-11
28
DESCRIPTION
Rev.
29
FRESH CRUDE TO
FRESH CRUDE TO
011-E-0003 A/D
011-E-0004 A/B
Rev.
TR Project No.: 02020 Page 97 of 193
30 FRESH CRUDE TO 011-E-0005
Rev.
31 FRESH CRUDE TO 011-E-0006
Rev.
32
Rev.
FRESH CRUDE TO 011-E-0007 A/D
----- TOTAL STREAM ----KG-MOL/HR
4743,9
4743,9
4743,9
4743,9
4743,9
KG/HR
1179247,0
1179247,0
1179247,0
1179247,0
1179247,0
TEMPERATURE
°C
58,1
81,0
92,4
97,8
104,8
PRESSURE
BAR(GA)
25,5
22,3
20,5
19,6
18,8
248,6
248,6
248,6
248,6
248,6
RATE
MOLECULAR WEIGHT KCAL/KG
-493,9
-482,7
-477,0
-474,2
-470,5
KCAL/HR
-5,82E+08
-5,69E+08
-5,62E+08
-5,59E+08
-5,55E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
4743,9
4743,9
4743,9
4743,9
4743,9
KG/HR
1179247,0
1179247,0
1179247,0
1179247,0
1179247,0
M3/HR
1367,3
1396,8
1412,2
1419,7
1429,5
GAL(US)/MIN
6020,1
6150,0
6217,6
6250,7
6294,1
M3/HR
1330,8
1330,8
1330,8
1330,8
1330,8
248,6
248,6
248,6
248,6
248,6
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-493,9
-482,7
-477,0
-474,2
-470,5
CP
KCAL/KG-C
0,479
0,504
0,517
0,522
0,529
DENSITY
KG/M3
862,5
844,2
835,1
830,6
824,9
0,277
0,233
0,211
0,200
0,190
Z FACTOR SURFACE TENSION
DYNE/CM
21,3
19,5
18,6
18,2
17,7
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,113
0,108
0,106
0,105
0,103
VISCOSITY
CP
6,7
4,5
3,5
3,2
2,8
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
REV: 03 Date: 12-MAY-11
33 FRESH CRUDE TO 011-E-0008
DESCRIPTION
Rev.
34 FRESH CRUDE TO 011-E-0009
Rev.
TR Project No.: 02020 Page 98 of 193
35 FRESH CRUDE TO DESALTER 011-X-0002
Rev.
36 DESALTED CRUDE TO 011-G-0002 A/B
Rev.
37
Rev.
DESALTED CRUDE TO 011-E-0011A/B 011-E-0012A/B
----- TOTAL STREAM ----KG-MOL/HR
4743,9
4743,9
4743,9
5293,4
5293,4
KG/HR
1179247,0
1179247,0
1179247,0
1189145,4
1189145,4
TEMPERATURE
°C
129,6
139,7
150,3
145,0
157,1
PRESSURE
BAR(GA)
16,2
15,6
15,1
12,0
32,6
248,6
248,6
248,6
224,6
224,6
RATE
MOLECULAR WEIGHT KCAL/KG
-457,1
-451,4
-445,4
-475,2
-467,9
KCAL/HR
-5,39E+08
-5,32E+08
-5,25E+08
-5,65E+08
-5,56E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
0,930
0,942
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,070
0,058
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
4743,9
4743,9
4743,9
5293,4
5293,4
KG/HR
1179247,0
1179247,0
1179247,0
1189145,4
1189145,4
M3/HR
1466,1
1481,8
1498,8
1498,5
1510,8
GAL(US)/MIN
6455,0
6524,0
6598,9
6597,6
6651,8
M3/HR
1330,8
1330,8
1330,8
1340,7
1340,7
248,6
248,6
248,6
224,6
224,6
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-457,1
-451,4
-445,4
-475,2
-467,9
CP
KCAL/KG-C
0,554
0,563
0,573
0,572
0,582
DENSITY
KG/M3
804,3
795,8
786,8
793,6
787,1
0,159
0,151
0,145
-
-
Z FACTOR SURFACE TENSION
DYNE/CM
15,9
15,1
14,4
-
-
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,097
0,094
0,090
0,102
0,098
VISCOSITY
CP
1,9
1,6
1,4
1,5
1,3
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
38
DESCRIPTION
DESALTED CRUDE TO 011-E-0013
Rev.
39 DESALTED CRUDE TO 011-E-0014 A/F
Rev.
TR Project No.: 02020 Page 99 of 193
40 DESALTED CRUDE TO 011-FV-0006
Rev.
41 DESALTED CRUDE TO 011-C-0001
Rev.
42
Rev.
PREFLASH OVERHEAD TO 011-D-0003
----- TOTAL STREAM ----KG-MOL/HR
5293,4
5293,4
5293,4
5293,4
2236,1
KG/HR
1189145,4
1189145,4
1189145,4
1189145,4
142333,2
TEMPERATURE
°C
167,6
179,7
200,0
188,9
110,2
PRESSURE
BAR(GA)
31,3
30,4
28,4
3,9
3,0
224,6
224,6
224,6
224,6
63,7
RATE
MOLECULAR WEIGHT KCAL/KG
-461,8
-454,6
-442,3
-442,3
-710,2
KCAL/HR
-5,49E+08
-5,41E+08
-5,26E+08
-5,26E+08
-1,01E+08
MOLE FRACTION LIQUID
0,955
1,000
1,000
0,734
0,224
MOLE FRACTION FREE WATER
0,045
0,000
0,000
0,000
0,063
KG-MOL/HR
-
-
-
1406,0
1593,0
KG/HR
-
-
-
84673,7
88610,6
M3/HR
-
-
-
10466,9
11871,1
M3/HR
-
-
-
33243,5
37665,3
-
-
-
60,2
55,6
-
-678,9
-753,3 0,514
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
CP
KCAL/KG-C
-
-
-
0,565
DENSITY
KG/M3
-
-
-
8,09
7,46
-
-
-
0,952
0,938
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
0,026
0,020
VISCOSITY
CP
-
-
-
0,01
0,01
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
5293,4
5293,4
5293,4
3887,4
643,1
KG/HR
1189145,4
1189145,4
1189145,4
1104471,6
53722,6
M3/HR
1527,4
1544,8
1583,2
1421,7
84,0
GAL(US)/MIN
6724,9
6801,5
6970,5
6259,6
370,0
M3/HR
1340,7
1340,7
1340,7
1217,9
74,2
224,6
224,6
224,6
284,1
83,5
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-461,8
-454,6
-442,3
-424,1
-639,2
CP
KCAL/KG-C
0,591
0,601
0,618
0,601
0,633
DENSITY
KG/M3
778,5
769,8
751,1
776,9
639,2
-
0,243
0,224
0,047
-
Z FACTOR SURFACE TENSION
DYNE/CM
-
15,6
14,0
14,4
-
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,098
0,105
0,094
0,094
0,091
VISCOSITY
CP
1,2
1,0
0,8
1,2
0,2
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
43
DESCRIPTION
MPS TO 011-C-0001
Rev.
44
Rev.
TR Project No.: 02020 Page 100 of 193
45 (2)
Rev.
46 (2)
Rev.
47
TOPPED CRUDE TO
TOPPED CRUDE TO
TOPPED CRUDE TO
TOPPED CRUDE TO
011-E-0016 A/B
011-E-0017 A/B
011-E-0018 A/B
011-E-0019 A/F
Rev.
----- TOTAL STREAM ----KG-MOL/HR
249,8
3804,0
3804,0
3804,0
3804,0
KG/HR
4500,0
1102062,9
1102062,9
1102062,9
1102062,9
TEMPERATURE
°C
250,0
201,1
222,4
229,0
242,4
PRESSURE
BAR(GA)
14,5
33,5
32,5
32,0
30,6
18,0
289,7
289,7
289,7
289,7
RATE
MOLECULAR WEIGHT KCAL/KG
-3103,7
-417,8
-404,6
-400,5
-392,0
KCAL/HR
-1,40E+07
-4,60E+08
-4,46E+08
-4,41E+08
-4,32E+08
MOLE FRACTION LIQUID
0,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
ENTHALPY
----- TOTAL VAPOR -----RATE
KG-MOL/HR
249,8
-
-
-
-
KG/HR
4500,0
-
-
-
-
M3/HR
662,7
-
-
-
-
M3/HR
5906,2
-
-
-
-
18,0
-
-
-
-
ENTHALPY
KCAL/KG
-3103,7
-
-
-
-
CP
KCAL/KG-C
0,580
-
-
-
-
DENSITY
KG/M3
6,79
-
-
-
-
0,945
-
-
-
-
STD. VAPOR RATE (1) MOLECULAR WEIGHT
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,035
-
-
-
-
VISCOSITY
CP
0,02
-
-
-
-
KG-MOL/HR
-
3804,0
3804,0
3804,0
3804,0
KG/HR
-
1102062,9
1102062,9
1102062,9
1102062,9
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
M3/HR
-
1419,5
1452,0
1462,6
1485,2
GAL(US)/MIN
-
6249,8
6392,9
6439,7
6539,4
M3/HR
-
1210,7
1210,7
1210,7
1210,7
-
289,7
289,7
289,7
289,7
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-417,8
-404,6
-400,5
-392,0
CP
KCAL/KG-C
-
0,609
0,627
0,632
0,643
DENSITY
KG/M3
-
776,4
759,0
753,5
742,0
-
0,326
0,310
0,304
0,288
Z FACTOR SURFACE TENSION
DYNE/CM
-
14,4
13,0
12,5
11,7
THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
0,097
0,090
0,089
0,084
VISCOSITY
CP
-
1,1
0,9
0,8
0,7
NOTES: (1) Standard conditions: 15°C and 1 atm. (2) Total flowrate through heat exchangers has been considered on the Heat and Material Balance for this stream.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
REV: 03 Date: 12-MAY-11
48 TOPPED CRUDE TO
DESCRIPTION
011-E-0020 A/F
Rev.
49 TOPPED CRUDE TO 011-F-0001
Rev.
TR Project No.: 02020 Page 101 of 193
50 TOPPED CRUDE TO 011-C-0002
Rev.
51 HAGO PA TO 011-G-0012 A/B
Rev.
52
Rev.
HAGO PA TO 011-C-0002
----- TOTAL STREAM ----KG-MOL/HR
3804,0
3804,0
3804,0
3534,6
2634,6
KG/HR
1102062,9
1102062,9
1102062,9
891640,1
664594,7
TEMPERATURE
°C
274,0
297,9
366,5
307,5
261,3
PRESSURE
BAR(GA)
28,6
26,4
2,0
1,4
1,4
289,7
289,7
289,7
252,3
252,3
RATE
MOLECULAR WEIGHT KCAL/KG
-371,3
-355,2
-292,6
-348,0
-379,7
KCAL/HR
-4,09E+08
-3,91E+08
-3,22E+08
-3,10E+08
-2,52E+08
MOLE FRACTION LIQUID
1,000
1,000
0,417
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
2218,5
-
-
KG/HR
-
-
359598,5
-
-
M3/HR
-
-
37037,0
-
-
M3/HR
-
-
52454,7
-
-
-
-
162,1
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-268,3
-
-
CP
KCAL/KG-C
-
-
0,685
-
-
DENSITY
KG/M3
-
-
9,71
-
-
-
-
0,946
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
0,031
-
-
VISCOSITY
CP
-
-
0,01
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
3804,0
3804,0
1585,5
3534,6
2634,6
KG/HR
1102062,9
1102062,9
742464,4
891640,1
664594,7
M3/HR
1543,2
1593,8
1034,1
1377,4
966,4
GAL(US)/MIN
6794,4
7017,4
4553,0
6064,4
4254,9
M3/HR
1210,7
1210,7
763,3
1026,7
765,2
289,7
289,7
468,3
252,3
252,3
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-371,3
-355,2
-304,3
-348,0
-379,7
CP
KCAL/KG-C
0,667
0,685
0,717
0,703
0,668
DENSITY
KG/M3
714,2
691,5
718,0
647,3
687,7
0,264
0,242
0,037
0,020
0,020
Z FACTOR SURFACE TENSION
DYNE/CM
9,8
8,4
9,9
9,4
12,2
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,072
0,063
0,078
0,081
0,092
VISCOSITY
CP
0,5
0,4
0,6
0,2
0,3
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
53
DESCRIPTION
HAGO TO 011-C-0006
Rev.
54 HAGO TO 011-G-0013 A/B
Rev.
TR Project No.: 02020 Page 102 of 193
55 HAGO TO 011-E-0009 A/B
Rev.
56 HAGO TO 011-E-0002
Rev.
57
Rev.
HAGO TO 011-A-0004
----- TOTAL STREAM ----KG-MOL/HR
528,4
412,6
412,6
412,6
412,6
KG/HR
133280,7
108875,4
108875,4
108875,4
108875,4
TEMPERATURE
°C
307,5
293,5
258,8
153,9
96,4
PRESSURE
BAR(GA)
1,4
1,5
13,2
12,2
11,5
252,3
263,9
263,9
263,9
263,9
RATE
MOLECULAR WEIGHT KCAL/KG
-348,0
-359,5
-382,9
-448,0
-479,5
KCAL/HR
-4,64E+07
-3,91E+07
-4,17E+07
-4,88E+07
-5,22E+07
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
0,999
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,001
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
528,4
412,6
412,6
412,6
412,6
KG/HR
133280,7
108875,4
108875,4
108875,4
108875,4
M3/HR
205,9
162,1
154,9
139,2
132,3
GAL(US)/MIN
906,5
713,6
682,1
613,1
582,7
M3/HR
153,5
124,2
124,2
124,2
124,2
252,3
263,9
263,9
263,9
263,9
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-348,0
-359,5
-382,9
-448,0
-479,5
CP
KCAL/KG-C
0,703
0,690
0,662
0,576
0,519
DENSITY
KG/M3
647,3
671,7
702,8
781,9
822,6
0,020
0,021
0,121
0,126
-
Z FACTOR SURFACE TENSION
DYNE/CM
9,4
11,0
13,2
20,3
-
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,081
0,091
0,098
0,118
0,127
VISCOSITY
CP
0,2
0,2
0,3
1,0
2,3
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
REV: 03 Date: 12-MAY-11
58 HAGO TO 011-E-0035
DESCRIPTION
Rev.
59 LAGO PA TO 011-G-0010 A/B
Rev.
TR Project No.: 02020 Page 103 of 193
60 LAGO PA TO 011-C-0002
Rev.
61 LAGO TO 011-C-0005
Rev.
62
Rev.
LAGO TO 011-G-0011 A/B
----- TOTAL STREAM ----KG-MOL/HR
412,6
4561,3
3594,7
722,5
585,5
KG/HR
108875,4
906367,3
714306,3
143560,4
120337,5
TEMPERATURE
°C
65,0
247,0
202,2
247,0
233,7
PRESSURE
BAR(GA)
10,8
1,3
1,3
1,3
1,3
263,9
198,7
198,7
198,7
205,5
RATE
MOLECULAR WEIGHT KCAL/KG
-495,3
-389,0
-418,5
-389,0
-399,7
KCAL/HR
-5,39E+07
-3,53E+08
-2,99E+08
-5,58E+07
-4,81E+07
MOLE FRACTION LIQUID
0,992
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,008
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
412,6
4561,3
3594,7
722,5
585,5
KG/HR
108875,4
906367,3
714306,3
143560,4
120337,5
M3/HR
129,0
1406,0
1043,6
222,7
180,9
GAL(US)/MIN
567,9
6190,3
4595,0
980,5
796,3
M3/HR
124,2
1096,7
864,3
173,7
144,6
263,9
198,7
198,7
198,7
205,5
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-495,3
-389,0
-418,5
-389,0
-399,7
CP
KCAL/KG-C
0,484
0,677
0,640
0,677
0,664
DENSITY
KG/M3
844,1
644,7
684,4
644,7
665,4
-
0,016
0,017
0,016
0,017
Z FACTOR SURFACE TENSION
DYNE/CM
-
10,4
13,5
10,4
12,0
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,131
0,085
0,095
0,085
0,092
VISCOSITY
CP
4,5
0,2
0,3
0,2
0,2
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
63
DESCRIPTION
LAGO TO 011-E-0006
Rev.
64 LAGO TO 011-E-0024
Rev.
TR Project No.: 02020 Page 104 of 193
65 LAGO TO 011-A-0003 A/B
Rev.
66 LAGO TO 011-E-0034
Rev.
67
Rev.
KERO PA TO 011-G-0008 A/B
----- TOTAL STREAM ----KG-MOL/HR
585,5
585,5
585,5
585,5
4611,8
KG/HR
120337,5
120337,5
120337,5
120337,5
667979,5
TEMPERATURE
°C
173,8
112,4
85,5
64,8
170,8
PRESSURE
BAR(GA)
13,3
12,6
12,1
11,4
1,1
205,5
205,5
205,5
205,5
144,8
RATE
MOLECULAR WEIGHT KCAL/KG
-437,8
-473,9
-488,6
-499,4
-439,7
KCAL/HR
-5,27E+07
-5,70E+07
-5,88E+07
-6,01E+07
-2,94E+08
MOLE FRACTION LIQUID
1,000
1,000
0,996
0,992
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,004
0,008
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
585,5
585,5
585,5
585,5
4611,8
KG/HR
120337,5
120337,5
120337,5
120337,5
667979,5
M3/HR
167,8
157,5
153,5
150,7
1032,9
GAL(US)/MIN
738,7
693,2
675,9
663,3
4547,9
M3/HR
144,6
144,6
144,6
144,6
861,2
205,5
205,5
205,5
205,5
144,8
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-437,8
-473,9
-488,6
-499,4
-439,7
CP
KCAL/KG-C
0,614
0,559
0,533
0,510
0,636
DENSITY
KG/M3
717,2
764,3
783,9
798,7
646,7
0,110
0,114
-
-
0,013
Z FACTOR SURFACE TENSION
DYNE/CM
16,3
21,0
-
-
11,8
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,105
0,116
0,120
0,123
0,089
VISCOSITY
CP
0,4
0,8
1,2
1,7
0,2
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
REV: 03 Date: 12-MAY-11
68 KERO PA TO 011-C-0002
DESCRIPTION
Rev.
69 KERO TO 011-C-0005
Rev.
TR Project No.: 02020 Page 105 of 193
70 KERO TO 011-G-0009 A/B
Rev.
71 KERO TO 011-E-0001
----- TOTAL STREAM -----
Rev.
72
KG-MOL/HR
3757,3
1261,5
920,1
920,1
3314,9
KG/HR
544216,4
182721,6
140901,8
140901,8
209977,7
TEMPERATURE
°C
123,7
170,8
217,4
144,4
93,0
PRESSURE
BAR(GA)
1,1
1,1
1,2
10,2
0,6
144,8
144,8
153,1
153,1
63,3
RATE
MOLECULAR WEIGHT KCAL/KG
-468,8
-439,7
-406,8
-453,4
-796,4
KCAL/HR
-2,55E+08
-8,03E+07
-5,73E+07
-6,39E+07
-1,67E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
0,211
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,092
KG-MOL/HR
-
-
-
-
2310,4
KG/HR
-
-
-
-
129085,8
M3/HR
-
-
-
-
42136,5
M3/HR
-
-
-
-
54628,3
-
-
-
-
55,9
ENTHALPY
Rev.
CDU OVERHEAD TO 011-A-0001 A/H
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-851,0
CP
KCAL/KG-C
-
-
-
-
0,483
DENSITY
KG/M3
-
-
-
-
3,06
-
-
-
-
0,966
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
0,017
VISCOSITY
CP
-
-
-
-
0,01
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
3757,3
1261,5
920,1
920,1
1004,5
KG/HR
544216,4
182721,6
140901,8
140901,8
80891,9
M3/HR
789,5
282,6
230,4
206,7
120,7
GAL(US)/MIN
3475,9
1244,1
1014,4
910,0
531,3
M3/HR
701,6
235,6
179,8
179,8
109,7
144,8
144,8
153,1
153,1
80,5
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-468,8
-439,7
-406,8
-453,4
-709,3
CP
KCAL/KG-C
0,595
0,636
0,673
0,609
0,622
DENSITY
KG/M3
689,4
646,7
611,6
681,7
670,4
0,014
0,013
0,014
0,072
-
Z FACTOR SURFACE TENSION
DYNE/CM
15,5
11,8
8,9
14,3
-
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,099
0,089
0,079
0,096
0,100
VISCOSITY
CP
0,3
0,2
0,2
0,3
0,3
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 106 of 193
STREAM Nº
73
74
75
76
DESCRIPTION
CDU OVERHEAD TO 011-D-0004
PREFLASH NAPHTHA FROM 011-E-0021
NAPHTHA TO 011-E-0021
NAPHTHA TO 011-D-0005
Rev.
77 (2)
Rev.
ATM. RESIDUE TO 011-C-0003
----- TOTAL STREAM ----KG-MOL/HR
3314,9
1602,9
2325,1
2325,1
1736,4
KG/HR
209977,7
89126,9
159793,3
159793,3
681752,5
TEMPERATURE
°C
57,0
65,0
69,0
43,0
407,0
PRESSURE
BAR(GA)
0,3
2,5
2,5
1,8
-0,6
63,3
55,6
68,7
68,7
392,6
RATE
MOLECULAR WEIGHT KCAL/KG
-910,5
-894,4
-725,7
-744,8
-297,2
KCAL/HR
-1,91E+08
-7,97E+07
-1,16E+08
-1,19E+08
-2,03E+08
MOLE FRACTION LIQUID
0,568
0,496
0,711
0,752
0,391
MOLE FRACTION FREE WATER
0,432
0,348
0,242
0,248
0,000
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1)
KG-MOL/HR
-
251,4
109,4
-
1056,7
KG/HR
-
14053,2
5932,8
-
208100,0
M3/HR
-
1899,2
840,4
-
145342,4
M3/HR
-
5944,0
2585,9
-
24986,0
-
55,9
54,2
-
196,9
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-561,2
-574,5
-
-344,1
CP
KCAL/KG-C
-
0,466
0,468
-
0,684
DENSITY
KG/M3
-
7,40
7,06
-
1,43
-
0,941
0,946
-
0,989
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
0,017
0,018
-
0,030
VISCOSITY
CP
-
0,01
0,01
-
0,01
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
3314,9
1351,5
2215,8
2325,1
679,7
KG/HR
209977,7
75073,7
153860,5
159793,3
473652,5
M3/HR
301,9
115,3
238,4
239,6
623,5
GAL(US)/MIN
1329,2
507,6
1049,6
1054,9
2745,2
M3/HR
287,8
108,1
222,4
232,6
463,5
63,3
55,5
69,4
68,7
696,9
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-910,5
-956,8
-731,5
-744,8
-276,6
CP
KCAL/KG-C
0,623
0,648
0,617
0,595
0,733
DENSITY
KG/M3
695,6
651,1
645,4
666,9
759,7
-
-
-
-
0,007
Z FACTOR SURFACE TENSION
DYNE/CM
-
-
-
-
12,4
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,109
0,098
0,092
0,098
0,102
VISCOSITY
CP
0,4
0,3
0,3
0,3
0,9
NOTES: (1) Standard conditions: 15°C and 1 atm. (2) Cracking in the vacuum heater has been considered.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
REV: 03 Date: 12-MAY-11
78
79
80
81
VAC. RESIDUE
VAC. RESIDUE TO 011-E-0018 A/D
VAC. RESIDUE TO 011-E-0014 A/F
HVGO TO 011-G-0017 A/B
TO 011-G-0018 A/B
DESCRIPTION
TR Project No.: 02020 Page 107 of 193
Rev.
82
Rev.
HVGO TO 011-E-0016 A/B
----- TOTAL STREAM ----KG-MOL/HR
534,9
534,9
404,5
2273,0
1708,6
KG/HR
460151,3
460151,3
347951,3
1057661,6
795061,6
TEMPERATURE
°C
359,2
308,0
270,5
320,9
280,0
PRESSURE
BAR(GA)
0,2
16,5
15,5
-0,9
19,4
860,3
860,3
860,3
465,3
465,3
RATE
MOLECULAR WEIGHT KCAL/KG
-312,3
-346,8
-370,8
-335,4
-362,9
KCAL/HR
-1,44E+08
-1,60E+08
-1,29E+08
-3,55E+08
-2,89E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
534,9
534,9
404,5
2273,0
1708,6
KG/HR
460151,3
460151,3
347951,3
1057661,6
795061,6
M3/HR
0,2
527,5
387,6
1450,1
1044,5
GAL(US)/MIN
0,7
2322,4
1706,7
6384,6
4598,7
M3/HR
436,9
436,9
330,4
1118,0
840,4
860,3
860,3
860,3
465,3
465,3
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-312,3
-346,8
-370,8
-335,4
-362,9
CP
KCAL/KG-C
2,907
0,656
0,626
0,695
0,664
DENSITY
KG/M3
837,3
872,4
897,6
729,4
761,2
0,003
0,357
0,350
0,002
0,271
Z FACTOR SURFACE TENSION
DYNE/CM
16,5
18,8
20,5
14,0
16,2
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,140
0,127
0,132
0,104
0,111
VISCOSITY
CP
2,8
5,4
8,1
0,6
0,9
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 108 of 193
STREAM Nº
83
84
85
86
DESCRIPTION
HVGO FROM 011-E-0016 A/B
MVGO TO 011-G-0016 A/B
MVGO + HVGO TO 011-E-0015 A/B
MVGO + HVGO TO 011-E-0010 A/B
Rev.
87
Rev.
LVGO TO 011-G-0015 A/B
----- TOTAL STREAM ----KG-MOL/HR
390,1
279,5
669,6
669,6
1864,5
KG/HR
181517,1
102000,0
283517,1
283517,1
505228,9
TEMPERATURE
°C
251,6
266,8
257,4
209,3
145,8
PRESSURE
BAR(GA)
18,7
-0,9
17,0
15,6
-0,9
465,3
364,9
423,4
423,4
271,0
RATE
MOLECULAR WEIGHT KCAL/KG
-381,4
-373,6
-378,3
-408,5
-450,5
KCAL/HR
-6,92E+07
-3,81E+07
-1,07E+08
-1,16E+08
-2,28E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
390,1
279,5
669,6
669,6
1864,5
KG/HR
181517,1
102000,0
283517,1
283517,1
505228,9
M3/HR
232,3
136,7
369,2
353,7
639,7
GAL(US)/MIN
1023,0
602,0
1625,5
1557,2
2816,4
M3/HR
191,9
110,9
302,8
302,8
574,2
465,3
364,9
423,4
423,4
271,0
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-381,4
-373,6
-378,3
-408,5
-450,5
CP
KCAL/KG-C
0,642
0,656
0,647
0,607
0,567
DENSITY
KG/M3
781,3
746,1
768,0
801,6
789,8
0,269
0,002
0,225
0,219
0,001
Z FACTOR SURFACE TENSION
DYNE/CM
17,7
15,1
16,7
19,4
20,7
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,115
0,106
0,112
0,119
0,117
VISCOSITY
CP
1,2
0,6
0,9
1,6
1,1
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 109 of 193
STREAM Nº
88
89
90
91
DESCRIPTION
LVGO TO 011-A-0005 A/H
LVGO TO 011-A-0005 A/H
OFF GAS TO 011-C-0007
BRINE TO WWT
Rev.
92
Rev.
HAGO PA TO NHDT UNIT
----- TOTAL STREAM ----KG-MOL/HR
1519,8
1519,8
19,9
5270,5
2371,0
KG/HR
411815,4
411815,4
721,5
95100,0
598100,0
TEMPERATURE
°C
126,5
60,0
41,5
41,5
307,5
PRESSURE
BAR(GA)
10,8
9,0
2,1
9,0
13,6
271,0
271,0
36,2
18,0
252,3
RATE
MOLECULAR WEIGHT KCAL/KG
-461,1
-495,2
-438,5
-3767,4
-347,9
KCAL/HR
-1,90E+08
-2,04E+08
-3,16E+05
-3,58E+08
-2,08E+08
MOLE FRACTION LIQUID
1,000
1,000
0,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
1,000
0,000
KG-MOL/HR
-
-
19,9
-
-
KG/HR
-
-
721,5
-
-
M3/HR
-
-
164,5
-
-
M3/HR
-
-
471,4
-
-
-
-
36,2
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-438,5
-
-
CP
KCAL/KG-C
-
-
0,398
-
-
DENSITY
KG/M3
-
-
4,39
-
-
-
-
0,978
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
0,021
-
-
VISCOSITY
CP
-
-
0,01
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
1519,8
1519,8
-
5270,5
2371,0
KG/HR
411815,4
411815,4
-
95100,0
598100,0
M3/HR
511,7
484,0
-
95,8
0,3
GAL(US)/MIN
2253,0
2130,8
-
421,7
1,1
M3/HR
468,0
468,0
-
95,2
688,7
271,0
271,0
-
18,0
252,3
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-461,1
-495,2
-
-3767,4
-347,9
CP
KCAL/KG-C
0,548
0,476
-
0,994
2,937
DENSITY
KG/M3
804,8
850,9
-
993,0
650,5
0,120
0,115
-
0,007
0,109
Z FACTOR SURFACE TENSION
DYNE/CM
22,0
26,7
-
69,6
9,4
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,121
0,131
-
0,540
0,094
VISCOSITY
CP
1,5
5,3
-
0,7
0,2
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 110 of 193
STREAM Nº
93
94
95
96
DESCRIPTION
HAGO PA FROM NHDT UNIT
LAGO PA TO NHDT UNIT
LAGO PA FROM NHDT UNIT
SOUR WATER TO SWS
Rev.
97
Rev.
LEAN AMINE
----- TOTAL STREAM ----KG-MOL/HR
2371,0
1962,7
1962,7
4254,5
351,9
KG/HR
598100,0
390000,0
390000,0
76644,8
8000,0
TEMPERATURE
°C
287,0
228,0
179,0
53,4
65,0
PRESSURE
BAR(GA)
11,1
11,6
9,1
7,0
2,0
252,3
198,7
198,7
18,0
22,7
RATE
MOLECULAR WEIGHT KCAL/KG
-362,2
-401,6
-433,0
-3751,0
-3076,9
KCAL/HR
-2,17E+08
-1,57E+08
-1,69E+08
-2,87E+08
-2,46E+07
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
1,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
2371,0
1962,7
1962,7
4254,5
351,9
KG/HR
598100,0
390000,0
390000,0
76644,8
8000,0
M3/HR
0,2
0,2
0,2
77,7
7,9
GAL(US)/MIN
1,1
0,7
0,7
342,2
34,9
M3/HR
688,7
471,9
471,9
76,8
7,8
252,3
198,7
198,7
18,0
22,7 -3076,9
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-362,2
-401,6
-433,0
-3751,0
CP
KCAL/KG-C
2,874
2,763
2,597
1,008
0,903
DENSITY
KG/M3
667,9
664,0
704,9
986,2
1009,8 0,002
0,090
0,083
0,068
0,005
SURFACE TENSION
DYNE/CM
10,6
11,7
15,2
67,1
62,2
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,100
0,104
0,116
0,557
0,437
VISCOSITY
CP
0,2
0,2
0,4
0,5
0,8
Z FACTOR
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
98
DESCRIPTION
RICH AMINE
Rev.
99 REFLUX 011-C-0001
Rev.
TR Project No.: 02020 Page 111 of 193
100 REFLUX 011-C-0002
Rev.
101
Rev.
HVGO TO 011-C-0003
----- TOTAL STREAM ----KG-MOL/HR
355,1
496,9
1160,1
1701,9
KG/HR
8122,5
50750,8
113504,3
791944,5
TEMPERATURE
°C
68,2
110,2
57,0
267,2
PRESSURE
BAR(GA)
2,0
3,7
1,0
-0,9
22,9
102,1
97,8
465,3
RATE
MOLECULAR WEIGHT KCAL/KG
-3027,3
-486,7
-512,9
-371,6
KCAL/HR
-2,46E+07
-2,47E+07
-5,82E+07
-2,94E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
KG/HR
-
-
-
-
M3/HR
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
VISCOSITY
CP
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
355,1
496,9
1160,1
1701,9
KG/HR
8122,5
50750,8
113504,3
791944,5
M3/HR
8,0
80,6
169,9
1030,4
GAL(US)/MIN
35,1
355,1
747,9
4536,9
M3/HR
MOLECULAR WEIGHT
8,0
71,1
161,5
837,1
22,9
102,1
97,8
465,3 -371,6
ENTHALPY
KCAL/KG
-3027,3
-486,7
-512,9
CP
KCAL/KG-C
0,886
0,614
0,569
0,655
DENSITY
KG/M3
1018,7
629,3
668,2
768,6 0,002
0,002
0,024
0,011
SURFACE TENSION
DYNE/CM
63,2
12,2
15,8
16,9
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,423
0,087
0,095
0,113
VISCOSITY
CP
0,8
0,2
0,3
1,0
Z FACTOR
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
6.
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 112 of 193
MAXI NAPHTHA CASE
The heat and material balance for the Maxi Naphtha Case (Naphtha/Kerosene cut point = 160°C) is included in this section. Stream numbers correspond to the streams identified in the Process Flow Diagrams: SA-JER-DS011-TRJR450004, SA-JER-DS011-TRJR-450023, SA-JER-DS011-TRJR-450005, SA-JER-DS011-TRJR-450006, SA-JERDS011-TRJR-450024, SA-JER-DS011-TRJR-450025 and SA-JER-DS011-TRJR-450039.
6.1.
STREAM COMPOSITIONS – MAXI NAPHTHA CASE
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
1 CRUDE
DESCRIPTION
Component
REV: 03 Date: 12-MAY-11 Rev.
2 WILD NAPHTHA
Rev.
3 TOTAL NAPHTHA
Rev.
TR Project No.: 02020 Page 113 of 193 4 KEROSENE TO LP HDS
Rev.
5
Rev.
KEROSENE TO STORAGE
Mass Frac (%)
H2O
0,00
0,00
2,91E-02
0,00
0,00
H2S
0,00
0,450
2,18E-02
0,00
0,00
HYDROGEN
0,00
0,00
0,00
0,00
0,00
AIR
0,00
0,00
0,00
0,00
0,00
METHANE
0,00
4,00E-02
1,94E-03
0,00
0,00
ETHANE
2,92E-02
0,520
0,221
0,00
0,00
ETHYLENE
0,00
0,00
0,00
0,00
0,00
PROPANE
0,441
1,73
3,04
0,00
0,00
PROPENE
0,00
0,00
0,00
0,00
0,00
IBUTANE
0,198
1,31
1,39
0,00
0,00 0,00
BUTANE
0,879
2,81
6,04
0,00
1-BUTENE
0,00
0,00
0,00
0,00
0,00
IPENTANE
0,614
2,48
4,24
0,00
0,00
PENTANE
1,12
2,33
7,61
0,00
0,00
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
0,154
5,59
1,30
0,00
0,00
NBP45*
0,404
3,51
2,88
0,00
0,00
NBP55.*
0,458
3,67
3,25
0,00
0,00
NBP65*
0,546
4,06
3,86
0,00
0,00
NBP75*
0,665
4,72
4,69
0,00
0,00
NBP85*
0,796
5,59
5,61
2,53E-04
2,53E-04
NBP95*
0,900
6,71
6,36
1,35E-03
1,35E-03
NBP105*
1,00
7,95
7,10
7,32E-03
7,32E-03
NBP115*
1,09
9,14
7,71
3,87E-02
3,87E-02
NBP125*
1,16
9,77
8,11
0,189
0,189
NBP135*
1,22
7,59
8,00
0,737
0,737
NBP145*
1,26
5,16
7,26
2,07
2,07
NBP155*
1,29
3,87
5,60
4,78
4,78
NBP165*
1,31
3,15
3,62
7,88
7,88
NBP175*
1,32
2,69
1,64
10,8
10,8
NBP185*
1,32
2,00
0,324
12,4
12,4
NBP195*
1,32
1,21
5,46E-02
12,3
12,3
NBP205*
1,32
0,949
7,99E-03
11,7
11,7
NBP215*
1,34
0,956
1,10E-03
10,8
10,8
NBP225*
1,36
3,54E-02
1,41E-04
9,52
9,52
NBP235*
1,39
0,00
0,00
7,76
7,76
NBP245*
1,42
0,00
0,00
5,22
5,22
NBP255*
1,44
0,00
0,00
2,62
2,62
NBP265*
1,46
0,00
0,00
0,899
0,899
NBP275*
1,48
0,00
0,00
0,234
0,234
NBP285*
1,50
0,00
0,00
3,65E-02
3,65E-02
NBP295*
1,51
0,00
0,00
6,02E-03
6,02E-03
NBP305*
1,52
0,00
0,00
8,72E-04
8,72E-04
NBP315*
1,53
0,00
0,00
1,02E-04
1,02E-04
NBP325*
1,54
0,00
0,00
0,00
0,00
NBP335*
1,55
0,00
0,00
0,00
0,00
NBP345*
1,54
0,00
0,00
0,00
0,00
NBP355*
1,53
0,00
0,00
0,00
0,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
1
REV: 03 Date: 12-MAY-11 Rev.
2
Rev.
3
Rev.
TR Project No.: 02020 Page 114 of 193 4
Rev.
5
CRUDE
WILD NAPHTHA
TOTAL NAPHTHA
KEROSENE TO LP HDS
NBP365*
1,51
0,00
0,00
0,00
0,00
NBP375*
1,47
0,00
0,00
0,00
0,00
NBP385*
1,43
0,00
0,00
0,00
0,00
NBP395*
1,39
0,00
0,00
0,00
0,00
NBP405*
1,36
0,00
0,00
0,00
0,00
NBP415*
1,33
0,00
0,00
0,00
0,00
NBP425*
1,30
0,00
0,00
0,00
0,00
NBP435*
1,28
0,00
0,00
0,00
0,00
NBP445*
1,27
0,00
0,00
0,00
0,00
NBP455*
1,26
0,00
0,00
0,00
0,00
NBP470*
2,51
0,00
0,00
0,00
0,00
NBP490*
2,73
0,00
0,00
0,00
0,00
NBP510*
2,90
0,00
0,00
0,00
0,00
NBP530*
2,81
0,00
0,00
0,00
0,00
NBP550*
4,22
0,00
0,00
0,00
0,00
NBP570*
1,80
0,00
0,00
0,00
0,00
NBP590*
1,75
0,00
0,00
0,00
0,00
NBP610*
1,67
0,00
0,00
0,00
0,00
NBP630*
1,56
0,00
0,00
0,00
0,00
NBP660*
2,88
0,00
0,00
0,00
0,00
NBP700*
2,66
0,00
0,00
0,00
0,00
NBP740*
2,50
0,00
0,00
0,00
0,00
NBP780*
2,39
0,00
0,00
0,00
0,00
NBP820*
2,27
0,00
0,00
0,00
0,00
NBP860*
2,21
0,00
0,00
0,00
0,00
NBP900*
2,21
0,00
0,00
0,00
0,00
NBP940*
2,21
0,00
0,00
0,00
0,00
NBP980*
2,21
0,00
0,00
0,00
0,00
DESCRIPTION
Component
KEROSENE TO STORAGE
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
6
REV: 03 Date: 12-MAY-11 Rev.
7
Rev.
8+9
Rev.
TR Project No.: 02020 Page 115 of 193 10+11
Rev.
12
LAGO TO LP HDS
LAGO TO STORAGE
HAGO TO HP HDS/ STORAGE
H2O
9,56E-02
9,56E-02
7,66E-02
5,84E-03
H2S
0,00
0,00
0,00
0,00
0,00
HYDROGEN
0,00
0,00
0,00
0,00
0,00
DESCRIPTION
Component
LVGO TO HP HDS/ STORAGE
HVGO TO DHC/MHC
2,51E-03
Rev.
Mass Frac (%)
AIR
0,00
0,00
0,00
0,00
0,00
METHANE
0,00
0,00
0,00
0,00
0,00
ETHANE
0,00
0,00
0,00
0,00
0,00
ETHYLENE
0,00
0,00
0,00
0,00
0,00
PROPANE
0,00
0,00
0,00
0,00
0,00
PROPENE
0,00
0,00
0,00
0,00
0,00
IBUTANE
0,00
0,00
0,00
0,00
0,00 0,00
BUTANE
0,00
0,00
0,00
0,00
1-BUTENE
0,00
0,00
0,00
0,00
0,00
IPENTANE
0,00
0,00
0,00
0,00
0,00
PENTANE
2,07E-04
2,07E-04
0,00
1,73E-04
0,00
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
0,00
0,00
0,00
0,00
0,00 0,00
NBP45*
1,65E-04
1,65E-04
0,00
0,00
NBP55.*
3,48E-04
3,48E-04
0,00
0,00
0,00
NBP65*
7,52E-04
7,52E-04
1,04E-04
0,00
0,00
NBP75*
1,61E-03
1,61E-03
2,13E-04
0,00
0,00
NBP85*
3,42E-03
3,42E-03
4,24E-04
0,00
0,00
NBP95*
6,86E-03
6,86E-03
7,99E-04
0,00
0,00
NBP105*
1,35E-02
1,35E-02
1,44E-03
0,00
0,00
NBP115*
2,58E-02
2,58E-02
2,48E-03
3,53E-03
1,99E-04
NBP125*
4,84E-02
4,84E-02
4,15E-03
7,88E-03
3,64E-04
NBP135*
8,83E-02
8,83E-02
6,96E-03
1,54E-02
5,72E-04
NBP145*
0,158
0,158
1,19E-02
2,60E-02
7,75E-04
NBP155*
0,290
0,290
2,10E-02
4,99E-02
1,11E-03
NBP165*
0,462
0,462
3,40E-02
8,26E-02
1,43E-03
NBP175*
0,688
0,688
5,29E-02
0,132
1,80E-03
NBP185*
1,03
1,03
8,18E-02
0,197
1,88E-03
NBP195*
1,47
1,47
0,124
0,274
2,01E-03
NBP205*
2,08
2,08
0,189
0,390
2,28E-03
NBP215*
2,93
2,93
0,284
0,520
2,52E-03
NBP225*
4,12
4,12
0,423
0,621
2,63E-03
NBP235*
5,83
5,83
0,620
0,722
2,86E-03
NBP245*
8,17
8,17
0,894
0,853
3,35E-03
NBP255*
10,5
10,5
1,23
0,906
3,67E-03
NBP265*
11,8
11,8
1,68
0,970
4,23E-03
NBP275*
12,0
12,0
2,25
1,16
5,66E-03
NBP285*
11,2
11,2
3,25
1,62
9,55E-03
NBP295*
9,97
9,97
4,52
2,37
1,69E-02
NBP305*
8,06
8,06
6,33
3,49
3,07E-02
NBP315*
5,39
5,39
8,78
5,18
5,74E-02
NBP325*
2,55
2,55
11,2
7,35
0,105
NBP335*
0,801
0,801
12,1
9,98
0,187
NBP345*
0,187
0,187
11,6
12,7
0,327
NBP355*
3,67E-02
3,67E-02
10,2
15,3
0,585
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
6
REV: 03 Date: 12-MAY-11 Rev.
7
Rev.
8+9
Rev.
TR Project No.: 02020 Page 116 of 193 10+11
Rev.
12
LAGO TO LP HDS
LAGO TO STORAGE
HAGO TO HP HDS/ STORAGE
NBP365*
6,40E-03
6,40E-03
8,45
16,2
1,11
NBP375*
9,95E-04
9,95E-04
6,44
12,4
2,24
NBP385*
1,35E-04
1,35E-04
4,39
5,03
3,79
NBP395*
0,00
0,00
2,57
1,13
4,81
NBP405*
0,00
0,00
1,28
0,189
5,26
NBP415*
0,00
0,00
0,549
2,72E-02
5,39
NBP425*
0,00
0,00
0,213
3,55E-03
5,38
NBP435*
0,00
0,00
7,67E-02
4,30E-04
5,32
NBP445*
0,00
0,00
2,61E-02
0,00
5,27
NBP455*
0,00
0,00
8,69E-03
0,00
5,22
NBP470*
0,00
0,00
3,26E-03
0,00
10,4
NBP490*
0,00
0,00
3,11E-04
0,00
11,2
NBP510*
0,00
0,00
0,00
0,00
11,3
NBP530*
0,00
0,00
0,00
0,00
8,84
NBP550*
0,00
0,00
0,00
0,00
9,52
NBP570*
0,00
0,00
0,00
0,00
2,32
NBP590*
0,00
0,00
0,00
0,00
0,939
NBP610*
0,00
0,00
0,00
0,00
0,269
NBP630*
0,00
0,00
0,00
0,00
5,90E-02
NBP660*
0,00
0,00
0,00
0,00
9,76E-03
NBP700*
0,00
0,00
0,00
0,00
2,99E-04
NBP740*
0,00
0,00
0,00
0,00
0,00
NBP780*
0,00
0,00
0,00
0,00
0,00
NBP820*
0,00
0,00
0,00
0,00
0,00
NBP860*
0,00
0,00
0,00
0,00
0,00
NBP900*
0,00
0,00
0,00
0,00
0,00
NBP940*
0,00
0,00
0,00
0,00
0,00
NBP980*
0,00
0,00
0,00
0,00
0,00
DESCRIPTION
Component
LVGO TO HP HDS/ STORAGE
HVGO TO DHC/MHC
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
13
DESCRIPTION
Component
REV: 03 Date: 12-MAY-11 Rev.
14
Rev.
15
Rev.
TR Project No.: 02020 Page 117 of 193 16
Rev.
17
HVGO TO STORAGE
VAC.RESIDUE TO STORAGE
VAC. RESIDUE TO DCU
PREFLASH OVERHEAD
NAPHTHA FROM PREFLASH
11,6
Rev.
Mass Frac (%)
H2O
2,51E-03
2,03E-03
2,03E-03
9,13
H2S
0,00
0,00
0,00
0,00
0,00
HYDROGEN
0,00
0,00
0,00
0,00
0,00
AIR
0,00
0,00
0,00
0,00
0,00
METHANE
0,00
0,00
0,00
0,00
0,00 0,383
ETHANE
0,00
0,00
0,00
0,244
ETHYLENE
0,00
0,00
0,00
0,00
0,00
PROPANE
0,00
0,00
0,00
3,65
5,64
PROPENE
0,00
0,00
0,00
0,00
0,00
IBUTANE
0,00
0,00
0,00
1,60
2,40
BUTANE
0,00
0,00
0,00
7,04
10,4
1-BUTENE
0,00
0,00
0,00
0,00
0,00
IPENTANE
0,00
0,00
0,00
4,68
6,50
PENTANE
0,00
0,00
0,00
8,48
11,5
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
0,00
0,00
0,00
1,16
1,55 3,89
NBP45*
0,00
0,00
0,00
2,99
NBP55.*
0,00
0,00
0,00
3,32
4,12
NBP65*
0,00
0,00
0,00
3,88
4,54
NBP75*
0,00
0,00
0,00
4,63
5,04
NBP85*
0,00
0,00
0,00
5,43
5,42
NBP95*
0,00
0,00
0,00
6,03
5,44
NBP105*
0,00
0,00
0,00
6,60
5,27
NBP115*
1,99E-04
0,00
0,00
7,02
4,86
NBP125*
3,64E-04
0,00
0,00
7,25
4,27
NBP135*
5,72E-04
0,00
0,00
7,10
3,49
NBP145*
7,75E-04
0,00
0,00
6,10
2,47
NBP155*
1,11E-03
0,00
0,00
2,91
0,911
NBP165*
1,43E-03
0,00
0,00
0,667
0,167
NBP175*
1,80E-03
0,00
0,00
9,85E-02
1,96E-02
NBP185*
1,88E-03
0,00
0,00
7,32E-03
1,05E-03
NBP195*
2,01E-03
0,00
0,00
7,30E-04
0,00
NBP205*
2,28E-03
0,00
0,00
0,00
0,00
NBP215*
2,52E-03
0,00
0,00
0,00
0,00
NBP225*
2,63E-03
0,00
0,00
0,00
0,00
NBP235*
2,86E-03
0,00
0,00
0,00
0,00
NBP245*
3,35E-03
0,00
0,00
0,00
0,00
NBP255*
3,67E-03
0,00
0,00
0,00
0,00
NBP265*
4,23E-03
0,00
0,00
0,00
0,00
NBP275*
5,66E-03
0,00
0,00
0,00
0,00
NBP285*
9,55E-03
0,00
0,00
0,00
0,00
NBP295*
1,69E-02
0,00
0,00
0,00
0,00
NBP305*
3,07E-02
0,00
0,00
0,00
0,00
NBP315*
5,74E-02
0,00
0,00
0,00
0,00
NBP325*
0,105
0,00
0,00
0,00
0,00
NBP335*
0,187
0,00
0,00
0,00
0,00
NBP345*
0,327
0,00
0,00
0,00
0,00
NBP355*
0,585
0,00
0,00
0,00
0,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 118 of 193
STREAM Nº
13
DESCRIPTION
HVGO TO STORAGE
VAC.RESIDUE TO STORAGE
VAC. RESIDUE TO DCU
PREFLASH OVERHEAD
NAPHTHA FROM PREFLASH
NBP365*
1,11
0,00
0,00
0,00
0,00
NBP375*
2,24
0,00
0,00
0,00
0,00
NBP385*
3,79
0,00
0,00
0,00
0,00
NBP395*
4,81
0,00
0,00
0,00
0,00
NBP405*
5,26
1,72E-04
1,72E-04
0,00
0,00
NBP415*
5,39
3,62E-04
3,62E-04
0,00
0,00
NBP425*
5,38
7,49E-04
7,49E-04
0,00
0,00
NBP435*
5,32
1,54E-03
1,54E-03
0,00
0,00
NBP445*
5,27
3,16E-03
3,16E-03
0,00
0,00
NBP455*
5,22
6,51E-03
6,51E-03
0,00
0,00
NBP470*
10,4
3,84E-02
3,84E-02
0,00
0,00
NBP490*
11,2
0,167
0,167
0,00
0,00
NBP510*
11,3
0,617
0,617
0,00
0,00
NBP530*
8,84
2,33
2,33
0,00
0,00
NBP550*
9,52
6,56
6,56
0,00
0,00
NBP570*
2,32
4,22
4,22
0,00
0,00
NBP590*
0,939
5,16
5,16
0,00
0,00
Component
Rev.
14
Rev.
15
Rev.
16
Rev.
17
Rev.
Mass Frac (%)
NBP610*
0,269
5,44
5,44
0,00
0,00
NBP630*
5,90E-02
5,24
5,24
0,00
0,00
NBP660*
9,76E-03
9,76
9,76
0,00
0,00
NBP700*
2,99E-04
9,00
9,00
0,00
0,00
NBP740*
0,00
8,47
8,47
0,00
0,00
NBP780*
0,00
8,09
8,09
0,00
0,00
NBP820*
0,00
7,68
7,68
0,00
0,00
NBP860*
0,00
7,49
7,49
0,00
0,00
NBP900*
0,00
7,49
7,49
0,00
0,00
NBP940*
0,00
7,49
7,49
0,00
0,00
NBP980*
0,00
4,72
4,72
0,00
0,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
18
DESCRIPTION
TOPPED CRUDE
Component
REV: 03 Date: 12-MAY-11 Rev.
19
Rev.
20
CDU OVERHEAD
ATM. RESIDUE
Rev.
TR Project No.: 02020 Page 119 of 193 21
Rev.
22
VDU OVERHEAD
RECOVERED OIL
Rev.
Mass Frac (%)
H2O
0,139
12,8
4,41E-02
75,0
2,38E-02
H2S
0,00
3,44E-02
0,00
0,404
2,48E-02
HYDROGEN
0,00
0,00
0,00
5,07E-03
0,00
AIR
0,00
0,00
0,00
0,126
8,73E-04
METHANE
0,00
3,06E-03
0,00
0,179
1,96E-03
ETHANE
2,72E-04
4,25E-02
0,00
0,168
7,51E-03
ETHYLENE
0,00
0,00
0,00
3,18E-02
1,08E-03
PROPANE
1,61E-02
0,292
0,00
0,234
3,18E-02
PROPENE
0,00
0,00
0,00
9,03E-02
1,07E-02
IBUTANE
1,84E-02
0,283
0,00
5,65E-02
1,82E-02
BUTANE
9,72E-02
1,18
0,00
0,271
0,115
1-BUTENE
0,00
0,00
0,00
0,102
3,86E-02
IPENTANE
0,132
1,50
0,00
0,146
0,136
PENTANE
0,263
2,79
0,00
0,231
0,263
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
3,97E-02
0,821
0,00
0,00
0,00
NBP45*
0,118
1,43
0,00
1,61E-04
2,38E-04
NBP55.*
0,157
1,84
0,00
5,34E-02
9,99E-02
NBP65*
0,218
2,47
0,00
4,55E-02
0,105
NBP75*
0,304
3,37
0,00
3,99E-02
0,111
NBP85*
0,414
4,52
0,00
3,33E-02
0,107
NBP95*
0,524
5,70
0,00
2,69E-02
9,74E-02
NBP105*
0,647
7,00
0,00
2,19E-02
8,62E-02
NBP115*
0,772
8,29
0,00
0,624
2,58
NBP125*
0,897
9,40
0,00
1,01
4,30
NBP135*
1,02
9,85
1,22E-04
1,40
6,03
NBP145*
1,14
9,49
1,93E-04
1,65
7,17
NBP155*
1,30
8,12
3,08E-04
2,02
8,79
NBP165*
1,39
5,58
4,56E-04
2,25
9,78
NBP175*
1,41
2,58
6,58E-04
2,39
10,4
NBP185*
1,41
0,512
9,64E-04
2,04
8,88
NBP195*
1,41
8,62E-02
1,43E-03
1,77
7,68
NBP205*
1,42
1,26E-02
2,17E-03
1,56
6,78
NBP215*
1,43
1,73E-03
3,37E-03
1,30
5,63
NBP225*
1,45
2,23E-04
5,33E-03
0,972
4,22
NBP235*
1,48
0,00
8,58E-03
0,720
3,13
NBP245*
1,51
0,00
1,39E-02
0,551
2,40
NBP255*
1,54
0,00
2,12E-02
0,387
1,68
NBP265*
1,57
0,00
3,26E-02
0,275
1,20
NBP275*
1,58
0,00
4,89E-02
0,221
0,962
NBP285*
1,60
0,00
8,44E-02
0,203
0,884
NBP295*
1,62
0,00
0,133
0,200
0,871
NBP305*
1,63
0,00
0,205
0,200
0,871
NBP315*
1,64
0,00
0,304
0,203
0,883
NBP325*
1,65
0,00
0,436
0,197
0,857
NBP335*
1,65
0,00
0,601
0,184
0,799
NBP345*
1,65
0,00
0,800
0,161
0,700
NBP355*
1,64
0,00
1,03
0,132
0,576
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 120 of 193
STREAM Nº
18
DESCRIPTION
TOPPED CRUDE
CDU OVERHEAD
ATM. RESIDUE
VDU OVERHEAD
RECOVERED OIL
NBP365*
1,61
0,00
1,27
9,55E-02
0,415
NBP375*
1,57
0,00
1,54
4,96E-02
0,216
NBP385*
1,53
0,00
1,80
1,36E-02
5,92E-02
NBP395*
1,49
0,00
2,03
2,07E-03
8,98E-03
NBP405*
1,46
0,00
2,18
2,31E-04
1,00E-03
NBP415*
1,42
0,00
2,24
0,00
0,00
NBP425*
1,40
0,00
2,25
0,00
0,00
NBP435*
1,37
0,00
2,23
0,00
0,00
NBP445*
1,36
0,00
2,22
0,00
0,00
NBP455*
1,34
0,00
2,20
0,00
0,00
NBP470*
2,69
0,00
4,40
0,00
0,00
NBP490*
2,92
0,00
4,79
0,00
0,00
NBP510*
3,10
0,00
5,08
0,00
0,00
NBP530*
3,01
0,00
4,93
0,00
0,00
NBP550*
4,52
0,00
7,40
0,00
0,00
NBP570*
1,93
0,00
3,16
0,00
0,00
NBP590*
1,87
0,00
3,07
0,00
0,00
NBP610*
1,79
0,00
2,93
0,00
0,00
NBP630*
1,67
0,00
2,74
0,00
0,00
NBP660*
3,08
0,00
5,05
0,00
0,00
NBP700*
2,84
0,00
4,66
0,00
0,00
NBP740*
2,68
0,00
4,39
0,00
0,00
NBP780*
2,56
0,00
4,19
0,00
0,00
NBP820*
2,42
0,00
3,97
0,00
0,00
NBP860*
2,37
0,00
3,88
0,00
0,00
NBP900*
2,37
0,00
3,88
0,00
0,00
NBP940*
2,37
0,00
3,88
0,00
0,00
NBP980*
2,37
0,00
3,88
0,00
0,00
Component
Rev.
19
Rev.
20
Rev.
21
Rev.
22
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
23 OFF GAS
DESCRIPTION
Component
REV: 03 Date: 12-MAY-11 Rev.
24
Rev.
25
WASHED OFF GAS
HAGO+LVGO TO HP HDS
Rev.
TR Project No.: 02020 Page 121 of 193 36 DESALTED CRUDE TO
Rev.
51
011-G-0002 A/B
HAGO PA TO 011-G-0012 A/B
2,90E-02
Rev.
Mass Frac (%)
H2O
4,48
4,26
5,81E-02
0,832
H2S
16,0
2,08E-02
1,33E-03
0,00
0,00
HYDROGEN
0,202
0,293
0,00
0,00
0,00
AIR
5,03
7,32
0,00
0,00
0,00
METHANE
7,13
10,4
1,05E-04
0,00
0,00 0,00
ETHANE
6,65
9,64
4,02E-04
2,90E-02
ETHYLENE
1,26
1,83
0,00
0,00
0,00
PROPANE
9,15
13,1
1,70E-03
0,437
3,83E-04
PROPENE
3,54
5,08
5,71E-04
0,00
0,00
IBUTANE
2,16
3,03
9,72E-04
0,197
6,25E-04 3,47E-03
BUTANE
10,2
14,1
6,14E-03
0,872
1-BUTENE
3,87
5,40
2,06E-03
0,00
0,00
IPENTANE
5,09
6,64
7,28E-03
0,609
6,78E-03 1,40E-02
PENTANE
7,77
9,86
1,40E-02
1,11
DEA
0,00
2,30E-04
0,00
0,00
0,00
NBP38*
0,00
0,00
0,00
0,153
2,24E-03
NBP45*
5,08E-03
6,15E-03
0,00
0,401
7,18E-03
NBP55.*
1,55
1,77
5,36E-03
0,454
1,07E-02
NBP65*
1,18
1,24
5,68E-03
0,541
1,65E-02
NBP75*
0,891
0,843
6,05E-03
0,659
2,57E-02
NBP85*
0,607
0,504
6,03E-03
0,789
3,87E-02
NBP95*
0,373
0,263
5,77E-03
0,893
5,48E-02
NBP105*
0,214
0,124
5,64E-03
0,994
7,53E-02
NBP115*
3,89
1,79
0,140
1,08
9,99E-02
NBP125*
3,65
1,31
0,233
1,15
0,129
NBP135*
2,63
0,715
0,329
1,21
0,164
NBP145*
1,49
0,308
0,396
1,25
0,209
NBP155*
0,635
8,94E-02
0,493
1,28
0,274
NBP165*
0,275
2,83E-02
0,563
1,30
0,334
NBP175*
0,106
0,00
0,619
1,31
0,392
NBP185*
1,92E-02
0,00
0,575
1,31
0,460
NBP195*
4,48E-03
0,00
0,559
1,31
0,542
NBP205*
1,01E-03
0,00
0,584
1,31
0,647
NBP215*
2,07E-04
0,00
0,621
1,33
0,783
NBP225*
0,00
0,00
0,669
1,35
0,960
NBP235*
0,00
0,00
0,776
1,38
1,19
NBP245*
0,00
0,00
0,965
1,40
1,49
NBP255*
0,00
0,00
1,18
1,43
1,83
NBP265*
0,00
0,00
1,50
1,45
2,26
NBP275*
0,00
0,00
1,94
1,47
2,79
NBP285*
0,00
0,00
2,77
1,48
3,71
NBP295*
0,00
0,00
3,85
1,50
4,84
NBP305*
0,00
0,00
5,41
1,51
6,44
NBP315*
0,00
0,00
7,57
1,52
8,57
NBP325*
0,00
0,00
9,78
1,53
10,5
NBP335*
0,00
0,00
11,1
1,53
11,1
NBP345*
0,00
0,00
11,3
1,53
10,4
NBP355*
0,00
0,00
10,8
1,52
9,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
23 OFF GAS
DESCRIPTION
Component
REV: 03 Date: 12-MAY-11 Rev.
24
Rev.
25
WASHED OFF GAS
HAGO+LVGO TO HP HDS
Rev.
TR Project No.: 02020 Page 122 of 193 36 DESALTED CRUDE TO
Rev.
51
011-G-0002 A/B
HAGO PA TO 011-G-0012 A/B
Rev.
Mass Frac (%)
NBP365*
0,00
0,00
9,74
1,49
7,33
NBP375*
0,00
0,00
7,43
1,46
5,52
NBP385*
0,00
0,00
4,30
1,42
3,72
NBP395*
0,00
0,00
2,12
1,38
2,17
NBP405*
0,00
0,00
0,971
1,35
1,07
NBP415*
0,00
0,00
0,405
1,32
0,457
NBP425*
0,00
0,00
0,155
1,29
0,176
NBP435*
0,00
0,00
5,57E-02
1,27
6,34E-02
NBP445*
0,00
0,00
1,89E-02
1,26
2,15E-02
NBP455*
0,00
0,00
6,31E-03
1,24
7,15E-03
NBP470*
0,00
0,00
2,37E-03
2,49
2,68E-03
NBP490*
0,00
0,00
2,25E-04
2,71
2,54E-04
NBP510*
0,00
0,00
0,00
2,87
0,00
NBP530*
0,00
0,00
0,00
2,79
0,00
NBP550*
0,00
0,00
0,00
4,19
0,00
NBP570*
0,00
0,00
0,00
1,79
0,00
NBP590*
0,00
0,00
0,00
1,73
0,00
NBP610*
0,00
0,00
0,00
1,66
0,00
NBP630*
0,00
0,00
0,00
1,55
0,00
NBP660*
0,00
0,00
0,00
2,86
0,00
NBP700*
0,00
0,00
0,00
2,64
0,00
NBP740*
0,00
0,00
0,00
2,48
0,00
NBP780*
0,00
0,00
0,00
2,37
0,00
NBP820*
0,00
0,00
0,00
2,25
0,00
NBP860*
0,00
0,00
0,00
2,19
0,00
NBP900*
0,00
0,00
0,00
2,19
0,00
NBP940*
0,00
0,00
0,00
2,19
0,00
NBP980*
0,00
0,00
0,00
2,19
0,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 123 of 193
STREAM Nº
53
DESCRIPTION
HAGO TO 011-C-0006
HAGO TO 011-G-0013 A/B
LAGO PA TO 011-G-0010 A/B
LAGO TO 011-C-0005
LAGO TO 011-G-0011 A/B
H2O
2,90E-02
7,66E-02
4,45E-02
4,45E-02
9,56E-02
H2S
0,00
0,00
0,00
0,00
0,00
HYDROGEN
0,00
0,00
0,00
0,00
0,00
Component
Rev.
54
Rev.
59
Rev.
61
Rev.
62
Rev.
Mass Frac (%)
AIR
0,00
0,00
0,00
0,00
0,00
METHANE
0,00
0,00
0,00
0,00
0,00
ETHANE
0,00
0,00
0,00
0,00
0,00
ETHYLENE
0,00
0,00
0,00
0,00
0,00
PROPANE
3,83E-04
0,00
5,83E-04
5,83E-04
0,00
PROPENE
0,00
0,00
0,00
0,00
0,00
IBUTANE
6,25E-04
0,00
1,02E-03
1,02E-03
0,00 0,00
BUTANE
3,47E-03
0,00
5,80E-03
5,80E-03
1-BUTENE
0,00
0,00
0,00
0,00
0,00
IPENTANE
6,78E-03
0,00
1,20E-02
1,20E-02
0,00
PENTANE
1,40E-02
0,00
2,51E-02
2,51E-02
2,07E-04
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
2,24E-03
0,00
4,06E-03
4,06E-03
0,00
NBP45*
7,18E-03
0,00
1,32E-02
1,32E-02
1,65E-04
NBP55.*
1,07E-02
0,00
2,00E-02
2,00E-02
3,48E-04
NBP65*
1,65E-02
1,04E-04
3,15E-02
3,15E-02
7,52E-04
NBP75*
2,57E-02
2,13E-04
4,99E-02
4,99E-02
1,61E-03
NBP85*
3,87E-02
4,24E-04
7,73E-02
7,73E-02
3,42E-03
NBP95*
5,48E-02
7,99E-04
0,113
0,113
6,86E-03
NBP105*
7,53E-02
1,44E-03
0,162
0,162
1,35E-02
NBP115*
9,99E-02
2,48E-03
0,226
0,226
2,58E-02
NBP125*
0,129
4,15E-03
0,311
0,311
4,84E-02
NBP135*
0,164
6,96E-03
0,423
0,423
8,83E-02
NBP145*
0,209
1,19E-02
0,575
0,575
0,158
NBP155*
0,274
2,10E-02
0,813
0,813
0,290
NBP165*
0,334
3,40E-02
1,06
1,06
0,462
NBP175*
0,392
5,29E-02
1,32
1,32
0,688
NBP185*
0,460
8,18E-02
1,67
1,67
1,03
NBP195*
0,542
0,124
2,11
2,11
1,47
NBP205*
0,647
0,189
2,68
2,68
2,08
NBP215*
0,783
0,284
3,47
3,47
2,93
NBP225*
0,960
0,423
4,55
4,55
4,12
NBP235*
1,19
0,620
6,10
6,10
5,83
NBP245*
1,49
0,894
8,17
8,17
8,17
NBP255*
1,83
1,23
10,1
10,1
10,5
NBP265*
2,26
1,68
11,1
11,1
11,8
NBP275*
2,79
2,25
11,0
11,0
12,0
NBP285*
3,71
3,25
10,1
10,1
11,2
NBP295*
4,84
4,52
8,83
8,83
9,97
NBP305*
6,44
6,33
7,05
7,05
8,06
NBP315*
8,57
8,78
4,66
4,66
5,39
NBP325*
10,5
11,2
2,19
2,19
2,55
NBP335*
11,1
12,1
0,684
0,684
0,801
NBP345*
10,4
11,6
0,159
0,159
0,187
NBP355*
9,00
10,2
3,11E-02
3,11E-02
3,67E-02
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 124 of 193
STREAM Nº
53
DESCRIPTION
HAGO TO 011-C-0006
HAGO TO 011-G-0013 A/B
LAGO PA TO 011-G-0010 A/B
LAGO TO 011-C-0005
LAGO TO 011-G-0011 A/B
NBP365*
7,33
8,45
5,40E-03
5,40E-03
6,40E-03
NBP375*
5,52
6,44
8,37E-04
8,37E-04
9,95E-04
NBP385*
3,72
4,39
1,13E-04
1,13E-04
1,35E-04
NBP395*
2,17
2,57
0,00
0,00
0,00
NBP405*
1,07
1,28
0,00
0,00
0,00
NBP415*
0,457
0,549
0,00
0,00
0,00
NBP425*
0,176
0,213
0,00
0,00
0,00
NBP435*
6,34E-02
7,67E-02
0,00
0,00
0,00
NBP445*
2,15E-02
2,61E-02
0,00
0,00
0,00
NBP455*
7,15E-03
8,69E-03
0,00
0,00
0,00
NBP470*
2,68E-03
3,26E-03
0,00
0,00
0,00
NBP490*
2,54E-04
3,11E-04
0,00
0,00
0,00
NBP510*
0,00
0,00
0,00
0,00
0,00
NBP530*
0,00
0,00
0,00
0,00
0,00
NBP550*
0,00
0,00
0,00
0,00
0,00
NBP570*
0,00
0,00
0,00
0,00
0,00
NBP590*
0,00
0,00
0,00
0,00
0,00
NBP610*
0,00
0,00
0,00
0,00
0,00
NBP630*
0,00
0,00
0,00
0,00
0,00
NBP660*
0,00
0,00
0,00
0,00
0,00
NBP700*
0,00
0,00
0,00
0,00
0,00
NBP740*
0,00
0,00
0,00
0,00
0,00
NBP780*
0,00
0,00
0,00
0,00
0,00
NBP820*
0,00
0,00
0,00
0,00
0,00
NBP860*
0,00
0,00
0,00
0,00
0,00
NBP900*
0,00
0,00
0,00
0,00
0,00
NBP940*
0,00
0,00
0,00
0,00
0,00
NBP980*
0,00
0,00
0,00
0,00
0,00
Component
Rev.
54
Rev.
59
Rev.
61
Rev.
62
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
67
DESCRIPTION
KERO PA TO
REV: 03 Date: 12-MAY-11 Rev.
69
Rev.
70
TR Project No.: 02020 Page 125 of 193 Rev.
75
77 (1)
NAPHTHA TO 011-E-0021
ATM. RESIDUE TO 011-C-0003
011-G-0008 A/B
KERO TO 011-C-0005
H2O
8,32E-02
8,32E-02
0,00
5,61
1,23
H2S
0,00
0,00
0,00
2,06E-02
2,06E-02
Component
KERO TO 011-G-0009 A/B
Rev.
Mass Frac (%)
HYDROGEN
0,00
0,00
0,00
0,00
2,58E-04
AIR
0,00
0,00
0,00
0,00
6,44E-03
METHANE
0,00
0,00
0,00
1,83E-03
9,13E-03
ETHANE
0,00
0,00
0,00
0,209
8,56E-03
ETHYLENE
0,00
0,00
0,00
0,00
1,62E-03
PROPANE
1,30E-03
1,30E-03
0,00
2,87
1,19E-02
PROPENE
0,00
0,00
0,00
0,00
4,60E-03
IBUTANE
2,52E-03
2,52E-03
0,00
1,32
2,88E-03 1,38E-02
BUTANE
1,44E-02
1,44E-02
0,00
5,70
1-BUTENE
0,00
0,00
0,00
0,00
5,21E-03
IPENTANE
3,32E-02
3,32E-02
0,00
4,01
7,44E-03
PENTANE
7,13E-02
7,13E-02
0,00
7,18
1,18E-02
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
1,49E-02
1,49E-02
0,00
1,23
0,00
NBP45*
4,19E-02
4,19E-02
0,00
2,72
0,00
NBP55.*
6,78E-02
6,78E-02
0,00
3,07
2,72E-03
NBP65*
0,115
0,115
0,00
3,65
2,32E-03
NBP75*
0,198
0,198
0,00
4,43
2,04E-03
NBP85*
0,337
0,337
2,53E-04
5,30
1,70E-03
NBP95*
0,538
0,538
1,35E-03
6,01
1,37E-03
NBP105*
0,848
0,848
7,32E-03
6,70
1,12E-03
NBP115*
1,31
1,31
3,87E-02
7,28
3,20E-02
NBP125*
1,97
1,97
0,189
7,66
5,20E-02
NBP135*
2,88
2,88
0,737
7,55
7,22E-02
NBP145*
4,15
4,15
2,07
6,85
8,57E-02
NBP155*
6,37
6,37
4,78
5,29
0,106
NBP165*
8,71
8,71
7,88
3,42
0,119
NBP175*
10,7
10,7
10,8
1,55
0,129
NBP185*
11,4
11,4
12,4
0,306
0,114
NBP195*
10,7
10,7
12,3
5,15E-02
0,104
NBP205*
9,81
9,81
11,7
7,55E-03
9,93E-02
NBP215*
8,85
8,85
10,8
1,04E-03
9,23E-02
NBP225*
7,65
7,65
9,52
1,33E-04
8,08E-02
NBP235*
6,14
6,14
7,76
0,00
7,30E-02
NBP245*
4,09
4,09
5,22
0,00
7,10E-02
NBP255*
2,04
2,04
2,62
0,00
6,53E-02
NBP265*
0,693
0,693
0,899
0,00
6,30E-02
NBP275*
0,179
0,179
0,234
0,00
7,03E-02
NBP285*
2,79E-02
2,79E-02
3,65E-02
0,00
9,34E-02
NBP295*
4,58E-03
4,58E-03
6,02E-03
0,00
0,133
NBP305*
6,62E-04
6,62E-04
8,72E-04
0,00
0,193
NBP315*
0,00
0,00
1,02E-04
0,00
0,287
NBP325*
0,00
0,00
0,00
0,00
0,411
NBP335*
0,00
0,00
0,00
0,00
0,573
NBP345*
0,00
0,00
0,00
0,00
0,765
NBP355*
0,00
0,00
0,00
0,00
0,997
NOTES: (1) Cracking in the vacuum heater has been considered.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
REV: 03 Date: 12-MAY-11 67
Rev.
69
Rev.
70
TR Project No.: 02020 Page 126 of 193 Rev.
75
77 (1)
011-G-0009 A/B
NAPHTHA TO 011-E-0021
ATM. RESIDUE TO 011-C-0003
011-G-0008 A/B
KERO TO 011-C-0005
NBP365*
0,00
0,00
0,00
0,00
1,26
NBP375*
0,00
0,00
0,00
0,00
1,54
NBP385*
0,00
0,00
0,00
0,00
1,82
NBP395*
0,00
0,00
0,00
0,00
2,06
NBP405*
0,00
0,00
0,00
0,00
2,20
NBP415*
0,00
0,00
0,00
0,00
2,24
NBP425*
0,00
0,00
0,00
0,00
2,24
NBP435*
0,00
0,00
0,00
0,00
2,21
NBP445*
0,00
0,00
0,00
0,00
2,19
NBP455*
0,00
0,00
0,00
0,00
2,17
NBP470*
0,00
0,00
0,00
0,00
4,35
NBP490*
0,00
0,00
0,00
0,00
4,73
NBP510*
0,00
0,00
0,00
0,00
5,02
NBP530*
0,00
0,00
0,00
0,00
4,87
NBP550*
0,00
0,00
0,00
0,00
7,31
NBP570*
0,00
0,00
0,00
0,00
3,12
NBP590*
0,00
0,00
0,00
0,00
3,02
NBP610*
0,00
0,00
0,00
0,00
2,89
NBP630*
0,00
0,00
0,00
0,00
2,70
NBP660*
0,00
0,00
0,00
0,00
4,98
NBP700*
0,00
0,00
0,00
0,00
4,59
NBP740*
0,00
0,00
0,00
0,00
4,33
NBP780*
0,00
0,00
0,00
0,00
4,13
NBP820*
0,00
0,00
0,00
0,00
3,92
NBP860*
0,00
0,00
0,00
0,00
3,82
NBP900*
0,00
0,00
0,00
0,00
3,82
NBP940*
0,00
0,00
0,00
0,00
3,82
NBP980*
0,00
0,00
0,00
0,00
2,41
KERO PA TO
DESCRIPTION
Component
KERO TO
Rev.
Mass Frac (%)
NOTES: (1) Cracking in the vacuum heater has been considered.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
78
REV: 03 Date: 12-MAY-11 81
Rev.
84
85
87
VAC. RESIDUE
DESCRIPTION
Component
TR Project No.: 02020 Page 127 of 193
TO 011-G-0018 A/B
HVGO TO 011-G-0017 A/B
MVGO TO 011-G-0016 A/B
MVGO + HVGO TO 011-E-0015 A/B
LVGO TO 011-G-0015 A/B
5,84E-03
Rev.
Mass Frac (%)
H2O
2,03E-03
2,14E-03
3,16E-03
2,51E-03
H2S
0,00
0,00
0,00
0,00
0,00
HYDROGEN
0,00
0,00
0,00
0,00
0,00
AIR
0,00
0,00
0,00
0,00
0,00
METHANE
0,00
0,00
0,00
0,00
0,00
ETHANE
0,00
0,00
0,00
0,00
0,00
ETHYLENE
0,00
0,00
0,00
0,00
0,00
PROPANE
0,00
0,00
0,00
0,00
0,00
PROPENE
0,00
0,00
0,00
0,00
0,00
IBUTANE
0,00
0,00
0,00
0,00
0,00
BUTANE
0,00
0,00
0,00
0,00
0,00
1-BUTENE
0,00
0,00
0,00
0,00
0,00
IPENTANE
0,00
0,00
0,00
0,00
0,00
PENTANE
0,00
0,00
0,00
0,00
1,73E-04
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
0,00
0,00
0,00
0,00
0,00
NBP45*
0,00
0,00
0,00
0,00
0,00
NBP55.*
0,00
0,00
0,00
0,00
0,00
NBP65*
0,00
0,00
0,00
0,00
0,00
NBP75*
0,00
0,00
0,00
0,00
0,00
NBP85*
0,00
0,00
0,00
0,00
0,00
NBP95*
0,00
0,00
0,00
0,00
0,00
NBP105*
0,00
0,00
0,00
0,00
0,00
NBP115*
0,00
1,44E-04
2,96E-04
1,99E-04
3,53E-03
NBP125*
0,00
2,58E-04
5,52E-04
3,64E-04
7,88E-03
NBP135*
0,00
3,96E-04
8,86E-04
5,72E-04
1,54E-02
NBP145*
0,00
5,21E-04
1,23E-03
7,75E-04
2,60E-02
NBP155*
0,00
7,20E-04
1,79E-03
1,11E-03
4,99E-02
NBP165*
0,00
9,12E-04
2,36E-03
1,43E-03
8,26E-02
NBP175*
0,00
1,12E-03
3,00E-03
1,80E-03
0,132
NBP185*
0,00
1,14E-03
3,20E-03
1,88E-03
0,197
NBP195*
0,00
1,19E-03
3,49E-03
2,01E-03
0,274
NBP205*
0,00
1,31E-03
4,00E-03
2,28E-03
0,390
NBP215*
0,00
1,41E-03
4,49E-03
2,52E-03
0,520
NBP225*
0,00
1,44E-03
4,75E-03
2,63E-03
0,621
NBP235*
0,00
1,53E-03
5,22E-03
2,86E-03
0,722
NBP245*
0,00
1,75E-03
6,18E-03
3,35E-03
0,853
NBP255*
0,00
1,88E-03
6,85E-03
3,67E-03
0,906
NBP265*
0,00
2,12E-03
7,99E-03
4,23E-03
0,970
NBP275*
0,00
2,78E-03
1,08E-02
5,66E-03
1,16
NBP285*
0,00
4,60E-03
1,84E-02
9,55E-03
1,62
NBP295*
0,00
7,97E-03
3,27E-02
1,69E-02
2,37
NBP305*
0,00
1,43E-02
6,00E-02
3,07E-02
3,49
NBP315*
0,00
2,62E-02
0,113
5,74E-02
5,18
NBP325*
0,00
4,69E-02
0,207
0,105
7,35
NBP335*
0,00
8,19E-02
0,374
0,187
9,98
NBP345*
0,00
0,139
0,664
0,327
12,7
NBP355*
0,00
0,231
1,21
0,585
15,3
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
78
REV: 03 Date: 12-MAY-11 81
Rev.
TR Project No.: 02020 Page 128 of 193
84
85
87 LVGO TO 011-G-0015 A/B
VAC. RESIDUE
TO 011-G-0018 A/B
HVGO TO 011-G-0017 A/B
MVGO TO 011-G-0016 A/B
MVGO + HVGO TO 011-E-0015 A/B
NBP365*
0,00
0,376
2,41
1,11
16,2
NBP375*
0,00
0,609
5,14
2,24
12,4
NBP385*
0,00
0,963
8,82
3,79
5,03
NBP395*
0,00
1,42
10,8
4,81
1,13
NBP405*
1,72E-04
1,95
11,2
5,26
0,189
NBP415*
3,62E-04
2,51
10,5
5,39
2,72E-02
NBP425*
7,49E-04
3,10
9,45
5,38
3,55E-03
NBP435*
1,54E-03
3,71
8,19
5,32
4,30E-04
NBP445*
3,16E-03
4,33
6,94
5,27
0,00
NBP455*
6,51E-03
4,94
5,72
5,22
0,00
NBP470*
3,84E-02
11,6
8,28
10,4
0,00
NBP490*
0,167
14,4
5,35
11,2
0,00
NBP510*
0,617
16,0
3,05
11,3
0,00
NBP530*
2,33
13,3
0,813
8,84
0,00
NBP550*
6,56
14,6
0,473
9,52
0,00
NBP570*
4,22
3,59
6,17E-02
2,32
0,00
NBP590*
5,16
1,46
1,33E-02
0,939
0,00
NBP610*
5,44
0,419
2,02E-03
0,269
0,00
NBP630*
5,24
9,20E-02
2,32E-04
5,90E-02
0,00
NBP660*
9,76
1,52E-02
0,00
9,76E-03
0,00
NBP700*
9,00
4,67E-04
0,00
2,99E-04
0,00
NBP740*
8,47
0,00
0,00
0,00
0,00
NBP780*
8,09
0,00
0,00
0,00
0,00
NBP820*
7,68
0,00
0,00
0,00
0,00
NBP860*
7,49
0,00
0,00
0,00
0,00
NBP900*
7,49
0,00
0,00
0,00
0,00
NBP940*
7,49
0,00
0,00
0,00
0,00
NBP980*
4,72
0,00
0,00
0,00
0,00
DESCRIPTION
Component
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 129 of 193
STREAM Nº
90
DESCRIPTION
OFF GAS TO 011-C-0007
BRINE TO WWT
SOUR WATER TO SWS
H2O
1,28
100,0
100,0
74,9
73,5
H2S
19,2
0,00
0,00
0,162
1,86
HYDROGEN
0,244
0,00
0,00
0,00
0,00
AIR
6,08
0,00
0,00
0,00
3,34E-04
METHANE
8,62
0,00
0,00
0,00
9,64E-04
ETHANE
8,01
0,00
0,00
0,00
1,11E-03
ETHYLENE
1,52
0,00
0,00
0,00
4,80E-04
PROPANE
10,9
0,00
0,00
0,00
1,24E-03
PROPENE
4,23
0,00
0,00
0,00
1,39E-03 1,93E-04
Component
Rev.
91 (1)
Rev.
96 (2)
Rev.
97 LEAN AMINE
Rev.
98
Rev.
RICH AMINE
Mass Frac (%)
IBUTANE
2,52
0,00
0,00
0,00
BUTANE
11,8
0,00
0,00
0,00
1,29E-03
1-BUTENE
4,49
0,00
0,00
0,00
1,10E-03
IPENTANE
5,52
0,00
0,00
0,00
3,01E-04
PENTANE
8,19
0,00
0,00
0,00
5,81E-04
DEA
0,00
0,00
0,00
25,0
24,6
NBP38*
0,00
0,00
0,00
0,00
0,00 0,00
NBP45*
5,10E-03
0,00
0,00
0,00
NBP55.*
1,47
0,00
0,00
0,00
0,00
NBP65*
1,03
0,00
0,00
0,00
0,00
NBP75*
0,700
0,00
0,00
0,00
0,00
NBP85*
0,419
0,00
0,00
0,00
0,00
NBP95*
0,218
0,00
0,00
0,00
0,00
NBP105*
0,103
0,00
0,00
0,00
0,00
NBP115*
1,49
0,00
0,00
0,00
0,00
NBP125*
1,09
0,00
0,00
0,00
0,00
NBP135*
0,594
0,00
0,00
0,00
0,00
NBP145*
0,255
0,00
0,00
0,00
0,00
NBP155*
7,42E-02
0,00
0,00
0,00
0,00
NBP165*
2,35E-02
0,00
0,00
0,00
0,00
NBP175*
6,59E-03
0,00
0,00
0,00
0,00
NBP185*
7,49E-04
0,00
0,00
0,00
0,00
NBP195*
1,21E-04
0,00
0,00
0,00
0,00
NBP205*
0,00
0,00
0,00
0,00
0,00
NBP215*
0,00
0,00
0,00
0,00
0,00
NBP225*
0,00
0,00
0,00
0,00
0,00
NBP235*
0,00
0,00
0,00
0,00
0,00
NBP245*
0,00
0,00
0,00
0,00
0,00
NBP255*
0,00
0,00
0,00
0,00
0,00
NBP265*
0,00
0,00
0,00
0,00
0,00
NBP275*
0,00
0,00
0,00
0,00
0,00
NBP285*
0,00
0,00
0,00
0,00
0,00
NBP295*
0,00
0,00
0,00
0,00
0,00
NBP305*
0,00
0,00
0,00
0,00
0,00
NBP315*
0,00
0,00
0,00
0,00
0,00
NBP325*
0,00
0,00
0,00
0,00
0,00
NBP335*
0,00
0,00
0,00
0,00
0,00
NBP345*
0,00
0,00
0,00
0,00
0,00
NBP355*
0,00
0,00
0,00
0,00
0,00
NOTES: (1) For details of the dissolved species on this stream refer to pertinent vendor document. (2) This stream may contain up to 60 pmm of H2S. This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 130 of 193
STREAM Nº
90
DESCRIPTION
OFF GAS TO 011-C-0007
BRINE TO WWT
SOUR WATER TO SWS
LEAN AMINE
RICH AMINE
NBP365*
0,00
0,00
0,00
0,00
0,00
NBP375*
0,00
0,00
0,00
0,00
0,00
NBP385*
0,00
0,00
0,00
0,00
0,00
NBP395*
0,00
0,00
0,00
0,00
0,00
NBP405*
0,00
0,00
0,00
0,00
0,00
NBP415*
0,00
0,00
0,00
0,00
0,00
NBP425*
0,00
0,00
0,00
0,00
0,00
NBP435*
0,00
0,00
0,00
0,00
0,00
NBP445*
0,00
0,00
0,00
0,00
0,00
NBP455*
0,00
0,00
0,00
0,00
0,00
NBP470*
0,00
0,00
0,00
0,00
0,00
NBP490*
0,00
0,00
0,00
0,00
0,00
NBP510*
0,00
0,00
0,00
0,00
0,00
NBP530*
0,00
0,00
0,00
0,00
0,00
NBP550*
0,00
0,00
0,00
0,00
0,00
NBP570*
0,00
0,00
0,00
0,00
0,00
NBP590*
0,00
0,00
0,00
0,00
0,00
NBP610*
0,00
0,00
0,00
0,00
0,00
NBP630*
0,00
0,00
0,00
0,00
0,00
NBP660*
0,00
0,00
0,00
0,00
0,00
NBP700*
0,00
0,00
0,00
0,00
0,00
NBP740*
0,00
0,00
0,00
0,00
0,00
NBP780*
0,00
0,00
0,00
0,00
0,00
NBP820*
0,00
0,00
0,00
0,00
0,00
NBP860*
0,00
0,00
0,00
0,00
0,00
NBP900*
0,00
0,00
0,00
0,00
0,00
NBP940*
0,00
0,00
0,00
0,00
0,00
NBP980*
0,00
0,00
0,00
0,00
0,00
Component
Rev.
91 (1)
Rev.
96 (2)
Rev.
97
Rev.
98
Rev.
Mass Frac (%)
NOTES: (1) For details of the dissolved species on this stream refer to pertinent vendor document. (2) This stream may contain up to 60 pmm of H2S. This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
99
DESCRIPTION
REFLUX 011-C-0001
REFLUX 011-C-0002
Component
Rev.
100
TR Project No.: 02020 Page 131 of 193
Rev.
Mass Frac (%)
H2O
0,260
5,86E-02
H2S
0,00
3,95E-02
HYDROGEN
0,00
0,00
AIR
0,00
0,00
METHANE
0,00
3,51E-03 4,87E-02
ETHANE
1,09E-02
ETHYLENE
0,00
0,00
PROPANE
0,351
0,334
PROPENE
0,00
0,00
IBUTANE
0,276
0,324
BUTANE
1,45
1,35
1-BUTENE
0,00
0,00
IPENTANE
1,73
1,72
PENTANE
3,56
3,20
DEA
0,00
0,00
NBP38*
0,526
0,941 1,64
NBP45*
1,55
NBP55.*
2,08
2,11
NBP65*
2,91
2,83
NBP75*
4,12
3,87
NBP85*
5,70
5,18
NBP95*
7,36
6,53
NBP105*
9,25
8,02
NBP115*
11,1
9,50
NBP125*
12,8
10,8
NBP135*
13,8
11,3
NBP145*
12,7
10,9
NBP155*
6,54
9,31
NBP165*
1,57
6,40
NBP175*
0,241
2,96
NBP185*
1,87E-02
0,587
NBP195*
1,90E-03
9,88E-02
NBP205*
1,87E-04
1,45E-02
NBP215*
0,00
1,98E-03
NBP225*
0,00
2,55E-04
NBP235*
0,00
0,00
NBP245*
0,00
0,00
NBP255*
0,00
0,00
NBP265*
0,00
0,00
NBP275*
0,00
0,00
NBP285*
0,00
0,00
NBP295*
0,00
0,00
NBP305*
0,00
0,00
NBP315*
0,00
0,00
NBP325*
0,00
0,00
NBP335*
0,00
0,00
NBP345*
0,00
0,00
NBP355*
0,00
0,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
99
DESCRIPTION
REFLUX 011-C-0001
REFLUX 011-C-0002
NBP365*
0,00
0,00
NBP375*
0,00
0,00
NBP385*
0,00
0,00
NBP395*
0,00
0,00
NBP405*
0,00
0,00
NBP415*
0,00
0,00
NBP425*
0,00
0,00
NBP435*
0,00
0,00
NBP445*
0,00
0,00
NBP455*
0,00
0,00
NBP470*
0,00
0,00
NBP490*
0,00
0,00
NBP510*
0,00
0,00
NBP530*
0,00
0,00
NBP550*
0,00
0,00
NBP570*
0,00
0,00
NBP590*
0,00
0,00
NBP610*
0,00
0,00
NBP630*
0,00
0,00
NBP660*
0,00
0,00
NBP700*
0,00
0,00
NBP740*
0,00
0,00
NBP780*
0,00
0,00
NBP820*
0,00
0,00
NBP860*
0,00
0,00
NBP900*
0,00
0,00
NBP940*
0,00
0,00
NBP980*
0,00
0,00
Component
Rev.
100
TR Project No.: 02020 Page 132 of 193
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
6.2.
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 133 of 193
PHYSICAL PROPERTIES – MAXI NAPHTHA CASE
STREAM Nº
1
DESCRIPTION
CRUDE
Rev.
2 WILD NAPHTHA
Rev.
3 TOTAL NAPHTHA
Rev.
4 KEROSENE TO LP HDS
Rev.
5
Rev.
KEROSENE TO STORAGE
----- TOTAL STREAM ----KG-MOL/HR
4743,9
90,5
1949,2
630,9
70,2
KG/HR
1179247,0
8500,0
175647,5
99800,0
11098,5
TEMPERATURE
°C
38,9
70,0
43,3
57,4
43,1
PRESSURE
BAR(GA)
2,0
5,0
7,0
7,0
7,0
248,6
93,9
90,1
158,2
158,2
RATE
MOLECULAR WEIGHT KCAL/KG
-503,4
-506,4
-531,2
-503,0
-510,4
KCAL/HR
-5,94E+08
-4,30E+06
-9,33E+07
-5,02E+07
-5,66E+06
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
4743,9
90,5
1949,2
630,9
70,2
KG/HR
1179247,0
8500,0
175647,5
99800,0
11098,5
M3/HR
1347,9
13,1
264,1
131,8
14,4
GAL(US)/MIN
5934,4
57,6
1163,0
580,1
63,6
M3/HR
1330,8
12,2
256,8
126,6
14,1
248,6
93,9
90,1
158,2
158,2
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-503,4
-506,4
-531,2
-503,0
-510,4
CP
KCAL/KG-C
0,457
0,582
0,561
0,526
0,511
DENSITY
KG/M3
874,9
649,9
665,0
757,4
768,4
0,033
0,030
0,041
0,061
0,063
Z FACTOR SURFACE TENSION
DYNE/CM
22,9
13,5
15,5
21,8
23,0
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,117
0,088
0,093
0,115
0,118
VISCOSITY
CP
9,3
0,3
0,3
0,8
1,0
NOTES: (1) Standard conditions: 15°C and 1 atm. This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
6
DESCRIPTION
LAGO TO LP HDS
Rev.
7 LAGO TO STORAGE
Rev.
TR Project No.: 02020 Page 134 of 193
8+9 HAGO TO HP HDS/ STORAGE
Rev.
10+11 LVGO TO HP HDS/ STORAGE
Rev.
12
Rev.
HVGO TO DHC/MHC
----- TOTAL STREAM ----KG-MOL/HR
529,5
58,8
415,9
122,5
602,7
KG/HR
108308,3
12034,0
108872,4
33200,3
255165,0
TEMPERATURE
°C
50,2
50,2
50,0
50,0
163,3
PRESSURE
BAR(GA)
7,0
7,0
7,5
7,5
13,3
204,5
204,5
261,7
271,0
423,4
RATE
MOLECULAR WEIGHT KCAL/KG
-506,9
-506,9
-502,7
-499,9
-435,5
KCAL/HR
-5,49E+07
-6,10E+06
-5,47E+07
-1,66E+07
-1,11E+08
MOLE FRACTION LIQUID
0,991
0,991
0,991
1,000
1,000
MOLE FRACTION FREE WATER
0,009
0,009
0,009
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
529,5
58,8
415,9
122,5
602,7
KG/HR
108308,3
12034,0
108872,4
33200,3
255165,0
M3/HR
134,1
14,9
127,7
38,7
306,3
GAL(US)/MIN
590,3
65,6
562,3
170,4
1348,6
M3/HR
130,3
14,5
124,4
37,7
272,5
204,5
204,5
261,7
271,0
423,4
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-506,9
-506,9
-502,7
-499,9
-435,5
CP
KCAL/KG-C
0,494
0,494
0,467
0,464
0,566
DENSITY
KG/M3
807,9
807,9
852,6
857,7
833,0
-
-
-
0,100
0,200
Z FACTOR SURFACE TENSION
DYNE/CM
-
-
-
27,4
22,1
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,125
0,125
0,133
0,133
0,126
VISCOSITY
CP
2,2
2,2
5,7
6,2
3,4
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
13
DESCRIPTION
HVGO TO STORAGE
Rev.
14 VAC.RESIDUE TO STORAGE
Rev.
TR Project No.: 02020 Page 135 of 193
15 VAC. RESIDUE TO DCU
Rev.
16 PREFLASH OVERHEAD
Rev.
17
Rev.
NAPHTHA FROM PREFLASH
----- TOTAL STREAM ----KG-MOL/HR
67,0
40,4
364,1
2237,0
1600,2
KG/HR
28352,0
34745,3
313205,2
142387,3
89023,6
TEMPERATURE
°C
90,0
180,0
202,6
138,2
110,1
PRESSURE
BAR(GA)
7,0
7,0
10,2
3,7
3,0
423,4
860,3
860,3
63,7
55,6
RATE
MOLECULAR WEIGHT KCAL/KG
-474,4
-424,1
-411,5
-661,4
-753,6
KCAL/HR
-1,34E+07
-1,47E+07
-1,29E+08
-9,42E+07
-6,71E+07
MOLE FRACTION LIQUID
1,000
1,000
1,000
0,000
0,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
2237,0
1600,2
KG/HR
-
-
-
142387,3
89023,6
M3/HR
-
-
-
15097,2
11964,4
M3/HR
-
-
-
52892,9
37836,3
-
-
-
63,7
55,6
-
-661,4
-753,6 0,514
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
CP
KCAL/KG-C
-
-
-
0,535
DENSITY
KG/M3
-
-
-
9,43
7,44
-
-
-
0,927
0,939
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
0,021
0,020
VISCOSITY
CP
-
-
-
0,01
0,01
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
67,0
40,4
364,1
-
-
KG/HR
28352,0
34745,3
313205,2
-
-
M3/HR
32,1
36,3
332,1
-
-
GAL(US)/MIN
141,5
159,7
1462,4
-
-
M3/HR
MOLECULAR WEIGHT
30,3
33,0
297,4
-
-
423,4
860,3
860,3
-
-
ENTHALPY
KCAL/KG
-474,4
-424,1
-411,5
-
-
CP
KCAL/KG-C
0,489
0,545
0,566
-
-
DENSITY
KG/M3
882,1
958,0
943,0
-
-
0,127
0,191
0,259
-
-
Z FACTOR SURFACE TENSION
DYNE/CM
26,5
24,8
23,7
-
-
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,137
0,144
0,141
-
-
VISCOSITY
CP
12,3
37,3
22,8
-
-
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
18
DESCRIPTION
TOPPED CRUDE
Rev.
19 CDU OVERHEAD
Rev.
TR Project No.: 02020 Page 136 of 193
20 ATM. RESIDUE
Rev.
21 VDU OVERHEAD
Rev.
22
Rev.
RECOVERED OIL
----- TOTAL STREAM ----KG-MOL/HR
3804,5
3114,2
1210,2
1516,7
54,3
KG/HR
1102128,5
202278,7
672532,6
34684,8
7977,1
TEMPERATURE
°C
186,9
129,7
350,8
83,2
50,3
PRESSURE
BAR(GA)
3,9
1,0
14,9
-0,9
7,5
289,7
65,0
555,7
22,9
146,9
RATE
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-426,8
-749,5
-317,3
-2478,6
-507,5
KCAL/HR
-4,70E+08
-1,52E+08
-2,13E+08
-8,60E+07
-4,05E+06
MOLE FRACTION LIQUID
1,000
-
1,000
0,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1)
KG-MOL/HR
-
3114,2
-
1516,7
-
KG/HR
-
202278,7
-
34684,8
-
M3/HR
-
49787,2
-
395867,2
-
M3/HR
-
73632,6
-
35862,3
-
-
65,0
-
22,9
-
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-749,5
-
-2478,6
-
CP
KCAL/KG-C
-
0,508
-
0,445
-
DENSITY
KG/M3
-
4,06
-
0,09
-
-
0,961
-
0,998
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
0,019
-
0,019
-
VISCOSITY
CP
-
0,01
-
0,01
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
3804,5
-
1210,2
-
54,3
KG/HR
1102128,5
-
672532,6
-
7977,1
M3/HR
1407,5
-
879,8
-
10,6
GAL(US)/MIN
6197,0
-
3873,7
-
46,6
M3/HR
1210,8
-
676,9
-
10,3
289,7
-
555,7
-
146,9
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-426,8
-
-317,3
-
-507,5
CP
KCAL/KG-C
0,599
-
0,701
-
0,524
DENSITY
KG/M3
783,0
-
764,4
-
753,3
0,047
-
0,223
-
0,062
Z FACTOR SURFACE TENSION
DYNE/CM
15,4
-
13,0
-
21,4
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,102
-
0,104
-
0,113
VISCOSITY
CP
1,3
-
0,9
-
0,8
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
23
DESCRIPTION
OFF GAS
Rev.
24 WASHED OFF GAS
Rev.
TR Project No.: 02020 Page 137 of 193
25 HAGO+LVGO TO HP HDS
Rev.
26 HAGO+LVGO TO STORAGE
Rev.
27
Rev.
FRESH CRUDE TO 011-E-0002
----- TOTAL STREAM ----KG-MOL/HR
22,8
16,8
559,0
33,8
4743,9
KG/HR
871,5
599,0
141500,0
8549,8
1179247,0
TEMPERATURE
°C
50,0
65,0
50,0
50,0
50,3
PRESSURE
BAR(GA)
0,3
1,8
7,5
7,0
26,2
38,2
35,7
253,1
253,1
248,6
RATE
MOLECULAR WEIGHT KCAL/KG
-527,8
-568,8
-502,3
-502,3
-497,6
KCAL/HR
-4,60E+05
-3,41E+05
-7,11E+07
-4,29E+06
-5,87E+08
MOLE FRACTION LIQUID
0,000
0,000
0,994
0,994
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,006
0,006
0,000
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1)
KG-MOL/HR
22,8
16,8
-
-
-
KG/HR
871,5
599,0
-
-
-
M3/HR
466,8
164,6
-
-
-
M3/HR
539,4
396,7
-
-
-
38,2
35,7
-
-
-
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-527,8
-568,8
-
-
-
CP
KCAL/KG-C
0,404
0,449
-
-
-
DENSITY
KG/M3
1,87
3,64
-
-
-
0,990
0,982
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,021
0,025
-
-
-
VISCOSITY
CP
0,01
0,01
-
-
-
KG-MOL/HR
-
-
559,0
33,8
4743,9
KG/HR
-
-
141500,0
8549,8
1179247,0
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
M3/HR
-
-
166,8
10,1
1357,8
GAL(US)/MIN
-
-
734,4
44,4
5978,1
M3/HR
-
-
162,6
9,8
1330,8
-
-
253,1
253,1
248,6
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-502,3
-502,3
-497,6
CP
KCAL/KG-C
-
-
0,470
0,470
0,469
DENSITY
KG/M3
-
-
848,3
848,3
868,5
-
-
-
-
0,290
Z FACTOR SURFACE TENSION
DYNE/CM
-
-
-
-
21,9
THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
0,131
0,131
0,115
VISCOSITY
CP
-
-
5,2
5,2
7,6
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
REV: 03 Date: 12-MAY-11
28
DESCRIPTION
Rev.
29
FRESH CRUDE TO
FRESH CRUDE TO
011-E-0003 A/D
011-E-0004 A/B
Rev.
TR Project No.: 02020 Page 138 of 193
30 FRESH CRUDE TO 011-E-0005
Rev.
31 FRESH CRUDE TO 011-E-0006
Rev.
32
Rev.
FRESH CRUDE TO 011-E-0007 A/D
----- TOTAL STREAM ----KG-MOL/HR
4743,9
4743,9
4743,9
4743,9
4743,9
KG/HR
1179247,0
1179247,0
1179247,0
1179247,0
1179247,0
TEMPERATURE
°C
56,6
81,1
92,5
98,0
105,0
PRESSURE
BAR(GA)
25,5
22,3
20,5
19,6
18,8
248,6
248,6
248,6
248,6
248,6
RATE
MOLECULAR WEIGHT KCAL/KG
-494,7
-482,7
-476,9
-474,0
-470,4
KCAL/HR
-5,83E+08
-5,69E+08
-5,62E+08
-5,59E+08
-5,55E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
4743,9
4743,9
4743,9
4743,9
4743,9
KG/HR
1179247,0
1179247,0
1179247,0
1179247,0
1179247,0
M3/HR
1365,5
1396,9
1412,4
1420,0
1429,8
GAL(US)/MIN
6012,0
6150,5
6218,4
6252,0
6295,3
M3/HR
1330,8
1330,8
1330,8
1330,8
1330,8
248,6
248,6
248,6
248,6
248,6
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-494,7
-482,7
-476,9
-474,0
-470,4
CP
KCAL/KG-C
0,477
0,505
0,517
0,522
0,530
DENSITY
KG/M3
863,6
844,2
834,9
830,5
824,8
0,278
0,233
0,211
0,200
0,190
Z FACTOR SURFACE TENSION
DYNE/CM
21,4
19,5
18,6
18,2
17,7
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,114
0,108
0,106
0,104
0,103
VISCOSITY
CP
6,9
4,5
3,5
3,2
2,8
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
REV: 03 Date: 12-MAY-11
33 FRESH CRUDE TO 011-E-0008
DESCRIPTION
Rev.
34 FRESH CRUDE TO 011-E-0009
Rev.
TR Project No.: 02020 Page 139 of 193
35 FRESH CRUDE TO DESALTER 011-X-0002
Rev.
36 DESALTED CRUDE TO 011-G-0002 A/B
Rev.
37
Rev.
DESALTED CRUDE TO 011-E-0011A/B 011-E-0012A/B
----- TOTAL STREAM ----KG-MOL/HR
4743,9
4743,9
4743,9
5293,4
5293,4
KG/HR
1179247,0
1179247,0
1179247,0
1189145,4
1189145,4
TEMPERATURE
°C
133,2
142,4
150,6
145,0
157,1
PRESSURE
BAR(GA)
16,2
15,6
15,1
12,0
32,6
248,6
248,6
248,6
224,6
224,6
RATE
MOLECULAR WEIGHT KCAL/KG
-455,1
-450,0
-445,3
-475,2
-467,9
KCAL/HR
-5,37E+08
-5,31E+08
-5,25E+08
-5,65E+08
-5,56E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
0,930
0,942
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,070
0,058
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
4743,9
4743,9
4743,9
5293,4
5293,4
KG/HR
1179247,0
1179247,0
1179247,0
1189145,4
1189145,4
M3/HR
1471,5
1485,9
1499,2
1498,5
1510,8
GAL(US)/MIN
6478,7
6542,1
6600,9
6597,6
6651,8
M3/HR
1330,8
1330,8
1330,8
1340,7
1340,7
248,6
248,6
248,6
224,6
224,6
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-455,1
-450,0
-445,3
-475,2
-467,9
CP
KCAL/KG-C
0,557
0,565
0,573
0,572
0,582
DENSITY
KG/M3
801,4
793,6
786,6
793,6
787,1
0,158
0,151
0,145
-
-
Z FACTOR SURFACE TENSION
DYNE/CM
15,6
15,0
14,4
-
-
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,096
0,093
0,090
0,102
0,098
VISCOSITY
CP
1,8
1,6
1,4
1,5
1,3
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
38
DESCRIPTION
DESALTED CRUDE TO 011-E-0013
Rev.
39 DESALTED CRUDE TO 011-E-0014 A/F
Rev.
TR Project No.: 02020 Page 140 of 193
40 DESALTED CRUDE TO 011-FV-0006
Rev.
41 DESALTED CRUDE TO 011-C-0001
Rev.
42
Rev.
PREFLASH OVERHEAD TO 011-D-0003
----- TOTAL STREAM ----KG-MOL/HR
5293,4
5293,4
5293,4
5293,4
2237,0
KG/HR
1189145,4
1189145,4
1189145,4
1189145,4
142387,3
TEMPERATURE
°C
169,5
179,1
200,0
188,9
110,1
PRESSURE
BAR(GA)
31,3
30,4
28,4
3,9
1,0
224,6
224,6
224,6
224,6
63,7
RATE
MOLECULAR WEIGHT KCAL/KG
-460,7
-455,0
-442,3
-442,3
-673,2
KCAL/HR
-5,48E+08
-5,41E+08
-5,26E+08
-5,26E+08
-9,59E+07
MOLE FRACTION LIQUID
0,957
1,000
1,000
0,734
0,000
MOLE FRACTION FREE WATER
0,043
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
1406,0
2237,0
KG/HR
-
-
-
84673,7
142387,3
M3/HR
-
-
-
10466,9
34109,2
M3/HR
-
-
-
33243,5
52892,9
-
-
-
60,2
63,7
-
-678,9
-673,2 0,495
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
CP
KCAL/KG-C
-
-
-
0,565
DENSITY
KG/M3
-
-
-
8,09
4,17
-
-
-
0,952
0,963
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
0,026
0,018
VISCOSITY
CP
-
-
-
0,01
0,01
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
5293,4
5293,4
5293,4
3887,4
-
KG/HR
1189145,4
1189145,4
1189145,4
1104471,6
-
M3/HR
1530,4
1543,7
1583,2
1421,7
-
GAL(US)/MIN
6738,3
6796,5
6970,5
6259,6
-
M3/HR
1340,7
1340,7
1340,7
1217,9
-
224,6
224,6
224,6
284,1
-
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-460,7
-455,0
-442,3
-424,1
-
CP
KCAL/KG-C
0,593
0,601
0,618
0,601
-
DENSITY
KG/M3
777,0
770,3
751,1
776,9
-
-
0,244
0,224
0,047
-
Z FACTOR SURFACE TENSION
DYNE/CM
-
15,6
14,0
14,4
-
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,098
0,106
0,094
0,094
-
VISCOSITY
CP
1,1
1,0
0,8
1,2
-
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
43
DESCRIPTION
MPS TO 011-C-0001
Rev.
44
Rev.
TR Project No.: 02020 Page 141 of 193
45 (2)
Rev.
46 (2)
Rev.
47
TOPPED CRUDE TO
TOPPED CRUDE TO
TOPPED CRUDE TO
TOPPED CRUDE TO
011-E-0016 A/B
011-E-0017 A/B
011-E-0018 A/B
011-E-0019 A/F
Rev.
----- TOTAL STREAM ----KG-MOL/HR
249,8
3804,5
3804,5
3804,5
3804,5
KG/HR
4500,0
1102128,5
1102128,5
1102128,5
1102128,5
TEMPERATURE
°C
250,0
201,1
222,4
230,4
243,8
PRESSURE
BAR(GA)
14,5
33,5
32,5
32,0
30,6
18,0
289,7
289,7
289,7
289,7
RATE
MOLECULAR WEIGHT KCAL/KG
-3103,7
-417,8
-404,6
-399,6
-391,1
KCAL/HR
-1,40E+07
-4,60E+08
-4,46E+08
-4,40E+08
-4,31E+08
MOLE FRACTION LIQUID
0,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
ENTHALPY
----- TOTAL VAPOR -----RATE
KG-MOL/HR
249,8
-
-
-
-
KG/HR
4500,0
-
-
-
-
M3/HR
662,7
-
-
-
-
M3/HR
5906,2
-
-
-
-
18,0
-
-
-
-
ENTHALPY
KCAL/KG
-3103,7
-
-
-
-
CP
KCAL/KG-C
0,580
-
-
-
-
DENSITY
KG/M3
6,79
-
-
-
-
0,945
-
-
-
-
STD. VAPOR RATE (1) MOLECULAR WEIGHT
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,035
-
-
-
-
VISCOSITY
CP
0,02
-
-
-
-
KG-MOL/HR
-
3804,5
3804,5
3804,5
3804,5
KG/HR
-
1102128,5
1102128,5
1102128,5
1102128,5
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
M3/HR
-
1419,6
1452,1
1465,0
1487,7
GAL(US)/MIN
-
6250,2
6393,4
6450,1
6550,2
M3/HR
-
1210,8
1210,8
1210,8
1210,8
-
289,7
289,7
289,7
289,7
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-417,8
-404,6
-399,6
-391,1
CP
KCAL/KG-C
-
0,609
0,627
0,633
0,644
DENSITY
KG/M3
-
776,4
759,0
752,3
740,8
-
0,326
0,310
0,304
0,288
Z FACTOR SURFACE TENSION
DYNE/CM
-
14,4
13,0
12,4
11,6
THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
0,097
0,090
0,088
0,083
VISCOSITY
CP
-
1,1
0,9
0,8
0,7
NOTES: (1) Standard conditions: 15°C and 1 atm. (2) Total flowrate through heat exchangers has been considered on the Heat and Material Balance for this sream.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
REV: 03 Date: 12-MAY-11
48 TOPPED CRUDE TO
DESCRIPTION
011-E-0020 A/F
Rev.
49 TOPPED CRUDE TO 011-F-0001
Rev.
TR Project No.: 02020 Page 142 of 193
50 TOPPED CRUDE TO 011-C-0002
Rev.
51 HAGO PA TO 011-G-0012 A/B
Rev.
52
Rev.
HAGO PA TO 011-C-0002
----- TOTAL STREAM ----KG-MOL/HR
3804,5
3804,5
3804,5
3608,5
2653,4
KG/HR
1102128,5
1102128,5
1102128,5
903827,6
664603,2
TEMPERATURE
°C
275,3
297,9
366,0
306,6
260,4
PRESSURE
BAR(GA)
28,6
26,4
2,0
1,4
1,4
289,7
289,7
289,7
250,5
250,5
RATE
MOLECULAR WEIGHT KCAL/KG
-370,4
-355,2
-293,0
-348,6
-380,3
KCAL/HR
-4,08E+08
-3,91E+08
-3,23E+08
-3,15E+08
-2,53E+08
MOLE FRACTION LIQUID
1,000
1,000
0,418
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
2213,6
-
-
KG/HR
-
-
358320,4
-
-
M3/HR
-
-
36925,6
-
-
M3/HR
-
-
52338,2
-
-
-
-
161,9
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-268,7
-
-
CP
KCAL/KG-C
-
-
0,685
-
-
DENSITY
KG/M3
-
-
9,70
-
-
-
-
0,946
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
0,031
-
-
VISCOSITY
CP
-
-
0,01
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
3804,5
3804,5
1591,0
3608,5
2653,4
KG/HR
1102128,5
1102128,5
743808,1
903827,6
664603,2
M3/HR
1545,9
1594,0
1035,8
1398,1
967,6
GAL(US)/MIN
6806,3
7018,0
4560,7
6155,8
4260,3
M3/HR
1210,8
1210,8
764,8
1042,2
766,4
289,7
289,7
467,5
250,5
250,5
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-370,4
-355,2
-304,7
-348,6
-380,3
CP
KCAL/KG-C
0,668
0,685
0,717
0,703
0,668
DENSITY
KG/M3
712,9
691,4
718,1
646,5
686,9
0,264
0,242
0,037
0,020
0,020
Z FACTOR SURFACE TENSION
DYNE/CM
9,7
8,4
10,0
9,3
12,2
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,072
0,063
0,078
0,081
0,092
VISCOSITY
CP
0,5
0,4
0,6
0,2
0,3
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
53
DESCRIPTION
HAGO TO 011-C-0006
Rev.
54 HAGO TO 011-G-0013 A/B
Rev.
TR Project No.: 02020 Page 143 of 193
55 HAGO TO 011-E-0009 A/B
Rev.
56 HAGO TO 011-E-0002
Rev.
57
Rev.
HAGO TO 011-A-0004
----- TOTAL STREAM ----KG-MOL/HR
533,0
415,9
415,9
415,9
415,9
KG/HR
133499,1
108872,4
108872,4
108872,4
108872,4
TEMPERATURE
°C
306,6
292,5
236,3
153,3
95,2
PRESSURE
BAR(GA)
1,4
1,5
13,2
12,2
11,5
250,5
261,7
261,7
261,7
261,7
RATE
MOLECULAR WEIGHT KCAL/KG
-348,6
-360,3
-397,6
-448,4
-480,3
KCAL/HR
-4,65E+07
-3,92E+07
-4,33E+07
-4,88E+07
-5,23E+07
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
0,998
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,002
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
533,0
415,9
415,9
415,9
415,9
KG/HR
133499,1
108872,4
108872,4
108872,4
108872,4
M3/HR
206,5
162,3
151,5
139,4
132,5
GAL(US)/MIN
909,2
714,6
666,9
613,9
583,2
M3/HR
153,9
124,4
124,4
124,4
124,4
250,5
261,7
261,7
261,7
261,7
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-348,6
-360,3
-397,6
-448,4
-480,3
CP
KCAL/KG-C
0,703
0,690
0,646
0,576
0,519
DENSITY
KG/M3
646,5
670,8
718,8
780,8
822,0
0,020
0,020
0,122
0,125
-
Z FACTOR SURFACE TENSION
DYNE/CM
9,3
11,0
14,6
20,3
-
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,081
0,091
0,103
0,118
0,127
VISCOSITY
CP
0,2
0,2
0,4
0,9
2,3
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
REV: 03 Date: 12-MAY-11
58 HAGO TO 011-E-0035
DESCRIPTION
Rev.
59 LAGO PA TO 011-G-0010 A/B
Rev.
TR Project No.: 02020 Page 144 of 193
60 LAGO PA TO 011-C-0002
Rev.
61 LAGO TO 011-C-0005
Rev.
62
Rev.
LAGO TO 011-G-0011 A/B
----- TOTAL STREAM ----KG-MOL/HR
415,9
4316,5
3289,8
729,0
588,4
KG/HR
108872,4
854886,7
651544,6
144372,0
120342,3
TEMPERATURE
°C
65,0
248,3
203,5
248,3
234,5
PRESSURE
BAR(GA)
10,8
1,3
1,3
1,3
1,3
261,7
198,1
198,1
198,1
204,5
RATE
MOLECULAR WEIGHT KCAL/KG
-495,5
-388,1
-417,7
-388,1
-399,1
KCAL/HR
-5,39E+07
-3,32E+08
-2,72E+08
-5,60E+07
-4,80E+07
MOLE FRACTION LIQUID
0,992
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,008
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
415,9
4316,5
3289,8
729,0
588,4
KG/HR
108872,4
854886,7
651544,6
144372,0
120342,3
M3/HR
129,2
1330,5
954,7
224,7
181,4
GAL(US)/MIN
568,9
5858,1
4203,4
989,3
798,7
M3/HR
124,4
1035,3
789,0
174,8
144,8
261,7
198,1
198,1
198,1
204,5
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-495,5
-388,1
-417,7
-388,1
-399,1
CP
KCAL/KG-C
0,485
0,678
0,642
0,678
0,665
DENSITY
KG/M3
842,6
642,5
682,5
642,5
663,4
-
0,016
0,017
0,016
0,017
Z FACTOR SURFACE TENSION
DYNE/CM
-
10,3
13,4
10,3
11,9
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,131
0,084
0,095
0,084
0,092
VISCOSITY
CP
4,3
0,2
0,3
0,2
0,2
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
63
DESCRIPTION
LAGO TO 011-E-0006
Rev.
64 LAGO TO 011-E-0024
Rev.
TR Project No.: 02020 Page 145 of 193
65 LAGO TO 011-A-0003 A/B
Rev.
66 LAGO TO 011-E-0034
Rev.
67
Rev.
KERO PA TO 011-G-0008 A/B
----- TOTAL STREAM ----KG-MOL/HR
588,4
588,4
588,4
588,4
5236,3
KG/HR
120342,3
120342,3
120342,3
120342,3
781088,9
TEMPERATURE
°C
177,1
116,3
85,5
64,8
177,6
PRESSURE
BAR(GA)
13,3
12,6
12,1
11,4
1,1
204,5
204,5
204,5
204,5
149,2
RATE
MOLECULAR WEIGHT KCAL/KG
-435,8
-471,7
-488,6
-499,4
-435,5
KCAL/HR
-5,24E+07
-5,68E+07
-5,88E+07
-6,01E+07
-3,40E+08
MOLE FRACTION LIQUID
1,000
1,000
0,996
0,993
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,004
0,007
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
588,4
588,4
588,4
588,4
5236,3
KG/HR
120342,3
120342,3
120342,3
120342,3
781088,9
M3/HR
168,7
158,3
153,7
150,9
1208,3
GAL(US)/MIN
742,6
696,9
676,7
664,2
5320,2
M3/HR
144,8
144,8
144,8
144,8
1001,2
204,5
204,5
204,5
204,5
149,2
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-435,8
-471,7
-488,6
-499,4
-435,5
CP
KCAL/KG-C
0,617
0,563
0,533
0,511
0,640
DENSITY
KG/M3
713,5
760,3
782,9
797,7
646,4
0,110
0,113
-
-
0,013
Z FACTOR SURFACE TENSION
DYNE/CM
16,0
20,6
-
-
11,7
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,104
0,116
0,120
0,123
0,089
VISCOSITY
CP
0,4
0,8
1,2
1,6
0,2
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
REV: 03 Date: 12-MAY-11
68 KERO PA TO 011-C-0002
DESCRIPTION
Rev.
69 KERO TO 011-C-0005
Rev.
TR Project No.: 02020 Page 146 of 193
70 KERO TO 011-G-0009 A/B
Rev.
71 KERO TO 011-E-0001
----- TOTAL STREAM -----
Rev.
72
KG-MOL/HR
4113,7
987,6
701,0
701,0
3114,2
KG/HR
613631,2
147323,3
110898,5
110898,5
202278,7
TEMPERATURE
°C
130,3
177,6
228,2
143,8
98,0
PRESSURE
BAR(GA)
1,1
1,1
1,2
11,0
0,6
149,2
149,2
158,2
158,2
65,0
RATE
MOLECULAR WEIGHT KCAL/KG
-464,8
-435,5
-399,7
-453,9
-800,0
KCAL/HR
-2,85E+08
-6,42E+07
-4,43E+07
-5,03E+07
-1,62E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
0,236
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,028
KG-MOL/HR
-
-
-
-
2292,6
KG/HR
-
-
-
-
115521,4
M3/HR
-
-
-
-
42468,8
M3/HR
-
-
-
-
54206,4
-
-
-
-
50,4
ENTHALPY
Rev.
CDU OVERHEAD TO 011-A-0001 A/H
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-990,9
CP
KCAL/KG-C
-
-
-
-
0,488
DENSITY
KG/M3
-
-
-
-
2,72
-
-
-
-
0,968
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
0,018
VISCOSITY
CP
-
-
-
-
0,01
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
4113,7
987,6
701,0
701,0
821,6
KG/HR
613631,2
147323,3
110898,5
110898,5
86757,3
M3/HR
890,5
227,9
182,4
161,1
129,1
GAL(US)/MIN
3920,8
1003,5
803,0
709,4
568,5
M3/HR
786,5
188,8
140,7
140,7
117,0
149,2
149,2
158,2
158,2
105,6
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-464,8
-435,5
-399,7
-453,9
-545,7
CP
KCAL/KG-C
0,599
0,640
0,680
0,606
0,598
DENSITY
KG/M3
689,1
646,4
608,1
688,3
672,0
0,014
0,013
0,014
0,080
-
Z FACTOR SURFACE TENSION
DYNE/CM
15,4
11,7
8,6
14,8
-
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,099
0,089
0,078
0,098
0,098
VISCOSITY
CP
0,3
0,2
0,2
0,3
0,3
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 147 of 193
STREAM Nº
73
74
75
76
DESCRIPTION
CDU OVERHEAD TO 011-D-0004
PREFLASH NAPHTHA FROM 011-E-0021
NAPHTHA TO 011-E-0021
NAPHTHA TO 011-D-0005
Rev.
77 (2)
Rev.
ATM. RESIDUE TO 011-C-0003
----- TOTAL STREAM ----KG-MOL/HR
3114,2
1600,2
2525,2
2525,2
1736,4
KG/HR
202278,7
89023,6
186023,2
186023,2
681752,5
TEMPERATURE
°C
64,8
65,0
72,0
43,0
407,0
PRESSURE
BAR(GA)
0,3
2,5
2,5
1,8
-0,6
65,0
55,6
73,7
73,7
392,6
RATE
MOLECULAR WEIGHT KCAL/KG
-919,0
-893,5
-691,9
-711,7
-297,2
KCAL/HR
-1,86E+08
-7,95E+07
-1,29E+08
-1,32E+08
-2,03E+08
MOLE FRACTION LIQUID
0,540
0,496
0,742
0,772
0,391
MOLE FRACTION FREE WATER
0,460
0,347
0,222
0,228
0,000
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1)
KG-MOL/HR
-
251,8
90,2
-
1056,7
KG/HR
-
14075,0
4844,4
-
208100,0
M3/HR
-
1902,0
701,0
-
145342,4
M3/HR
-
5952,6
2133,1
-
24986,0
-
55,9
53,7
-
196,9
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-561,2
-584,9
-
-344,1
CP
KCAL/KG-C
-
0,466
0,470
-
0,684
DENSITY
KG/M3
-
7,40
6,91
-
1,43
-
0,941
0,948
-
0,989
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
0,017
0,018
-
0,030
VISCOSITY
CP
-
0,01
0,01
-
0,01
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
3114,2
1348,5
2434,9
2525,2
679,7
KG/HR
202278,7
74948,6
181178,9
186023,2
473652,5
M3/HR
287,2
115,1
277,9
274,8
623,5
GAL(US)/MIN
1264,7
506,9
1223,6
1209,8
2745,2
M3/HR
271,9
107,9
258,9
267,2
463,5
65,0
55,6
74,4
73,7
696,9
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-919,0
-955,9
-694,7
-711,7
-276,6
CP
KCAL/KG-C
0,625
0,648
0,611
0,586
0,733
DENSITY
KG/M3
704,2
651,0
651,9
677,0
759,7
-
-
-
-
0,007
Z FACTOR SURFACE TENSION
DYNE/CM
-
-
-
-
12,4
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,111
0,098
0,092
0,099
0,102
VISCOSITY
CP
0,4
0,3
0,3
0,3
0,9
NOTES: (1) Standard conditions: 15°C and 1 atm. (2) Cracking in the vacuum heater has been considered.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
REV: 03 Date: 12-MAY-11
78
79
80
81
VAC. RESIDUE
VAC. RESIDUE TO 011-E-0018 A/D
VAC. RESIDUE TO 011-E-0014 A/F
HVGO TO 011-G-0017 A/B
TO 011-G-0018 A/B
DESCRIPTION
TR Project No.: 02020 Page 148 of 193
Rev.
82
Rev.
HVGO TO 011-E-0016 A/B
----- TOTAL STREAM ----KG-MOL/HR
534,9
534,9
404,5
2273,0
1708,7
KG/HR
460150,4
460150,4
347950,4
1057658,4
795058,4
TEMPERATURE
°C
360,2
308,0
275,0
320,9
280,0
PRESSURE
BAR(GA)
-0,8
16,5
15,5
-0,9
19,4
860,3
860,3
860,3
465,3
465,3
RATE
MOLECULAR WEIGHT KCAL/KG
-311,7
-346,8
-368,0
-335,4
-362,9
KCAL/HR
-1,43E+08
-1,60E+08
-1,28E+08
-3,55E+08
-2,89E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
534,9
534,9
404,5
2273,0
1708,7
KG/HR
460150,4
460150,4
347950,4
1057658,4
795058,4
M3/HR
550,0
527,5
388,9
1450,1
1044,5
GAL(US)/MIN
2421,5
2322,4
1712,4
6384,7
4598,7
M3/HR
436,9
436,9
330,4
1118,0
840,4
860,3
860,3
860,3
465,3
465,3
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-311,7
-346,8
-368,0
-335,4
-362,9
CP
KCAL/KG-C
0,695
0,656
0,630
0,695
0,664
DENSITY
KG/M3
836,6
872,4
894,7
729,4
761,2
0,003
0,357
0,348
0,002
0,271
Z FACTOR SURFACE TENSION
DYNE/CM
16,4
18,8
20,3
14,0
16,2
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,120
0,127
0,132
0,104
0,111
VISCOSITY
CP
2,7
5,4
7,7
0,6
0,9
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 149 of 193
STREAM Nº
83
84
85
86
DESCRIPTION
HVGO FROM 011-E-0016 A/B
MVGO TO 011-G-0016 A/B
MVGO + HVGO TO 011-E-0015 A/B
MVGO + HVGO TO 011-E-0010 A/B
Rev.
87
Rev.
LVGO TO 011-G-0015 A/B
----- TOTAL STREAM ----KG-MOL/HR
390,1
279,5
669,6
669,6
1864,4
KG/HR
181517,1
101999,9
283517,0
283517,0
505204,1
TEMPERATURE
°C
251,6
266,8
257,4
209,3
145,8
PRESSURE
BAR(GA)
18,7
-0,9
17,0
15,6
-0,9
465,3
364,9
423,4
423,4
271,0
RATE
MOLECULAR WEIGHT KCAL/KG
-381,4
-373,5
-378,3
-408,5
-450,5
KCAL/HR
-6,92E+07
-3,81E+07
-1,07E+08
-1,16E+08
-2,28E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
390,1
279,5
669,6
669,6
1864,4
KG/HR
181517,1
101999,9
283517,0
283517,0
505204,1
M3/HR
232,3
136,7
369,2
353,7
639,7
GAL(US)/MIN
1023,0
602,0
1625,5
1557,2
2816,3
M3/HR
191,9
110,9
302,8
302,8
574,2
465,3
364,9
423,4
423,4
271,0
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-381,4
-373,5
-378,3
-408,5
-450,5
CP
KCAL/KG-C
0,642
0,656
0,647
0,607
0,567
DENSITY
KG/M3
781,2
746,0
767,9
801,6
789,8
0,269
0,002
0,225
0,219
0,001
Z FACTOR SURFACE TENSION
DYNE/CM
17,7
15,1
16,7
19,4
20,7
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,115
0,106
0,112
0,119
0,117
VISCOSITY
CP
1,2
0,6
0,9
1,6
1,1
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 150 of 193
STREAM Nº
88
89
90
91
DESCRIPTION
LVGO TO 011-A-0005 A/H
LVGO TO 011-A-0005 A/H
OFF GAS TO 011-C-0007
BRINE TO WWT
Rev.
92
Rev.
HAGO PA TO NHDT UNIT
----- TOTAL STREAM ----KG-MOL/HR
1519,7
1519,7
19,9
5270,5
2387,9
KG/HR
411804,1
411804,1
721,5
95100,0
598100,0
TEMPERATURE
°C
126,5
60,0
41,5
41,5
306,6
PRESSURE
BAR(GA)
10,8
9,0
2,1
9,0
13,6
271,0
271,0
36,2
18,0
250,5
RATE
MOLECULAR WEIGHT KCAL/KG
-461,1
-495,2
-438,5
-3767,4
-348,5
KCAL/HR
-1,90E+08
-2,04E+08
-3,16E+05
-3,58E+08
-2,08E+08
MOLE FRACTION LIQUID
1,000
1,000
0,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
1,000
0,000
KG-MOL/HR
-
-
19,9
-
-
KG/HR
-
-
721,5
-
-
M3/HR
-
-
164,5
-
-
M3/HR
-
-
471,4
-
-
-
-
36,2
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-438,5
-
-
CP
KCAL/KG-C
-
-
0,398
-
-
DENSITY
KG/M3
-
-
4,39
-
-
-
-
0,978
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
0,021
-
-
VISCOSITY
CP
-
-
0,01
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
1519,7
1519,7
-
5270,5
2387,9
KG/HR
411804,1
411804,1
-
95100,0
598100,0
M3/HR
511,7
483,9
-
95,8
0,3
GAL(US)/MIN
2252,9
2130,7
-
421,7
1,1
M3/HR
468,0
468,0
-
95,2
689,7
271,0
271,0
-
18,0
250,5
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-461,1
-495,2
-
-3767,4
-348,5
CP
KCAL/KG-C
0,548
0,476
-
0,994
2,937
DENSITY
KG/M3
804,8
850,9
-
993,0
649,6
0,120
0,115
-
0,007
0,109
Z FACTOR SURFACE TENSION
DYNE/CM
22,0
26,7
-
69,6
9,3
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,121
0,131
-
0,540
0,094
VISCOSITY
CP
1,5
5,3
-
0,7
0,2
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 151 of 193
STREAM Nº
93
94 (2)
95 (2)
96
DESCRIPTION
HAGO PA FROM NHDT UNIT
LAGO PA TO NHDT UNIT
LAGO PA FROM NHDT UNIT
SOUR WATER TO SWS
Rev.
97
Rev.
LEAN AMINE
----- TOTAL STREAM ----KG-MOL/HR
2387,9
1842,9
1842,9
4254,2
351,9
KG/HR
598100,0
365000,0
365000,0
76639,3
8000,0
TEMPERATURE
°C
287,0
233,0
178,0
56,1
65,0
PRESSURE
BAR(GA)
11,1
11,6
9,1
7,1
2,0
250,5
198,1
198,1
18,0
22,7
RATE
MOLECULAR WEIGHT KCAL/KG
-362,2
-398,3
-433,7
-3748,3
-3076,9
KCAL/HR
-2,17E+08
-1,45E+08
-1,58E+08
-2,87E+08
-2,46E+07
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
1,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
2387,9
1842,9
1842,9
4254,2
351,9
KG/HR
598100,0
365000,0
365000,0
76639,3
8000,0
M3/HR
0,2
0,2
0,1
77,8
7,9
GAL(US)/MIN
1,1
0,7
0,6
342,6
34,9
M3/HR
689,7
442,0
442,0
76,8
7,8
250,5
198,1
198,1
18,0
22,7 -3076,9
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-362,2
-398,3
-433,7
-3748,3
CP
KCAL/KG-C
2,876
2,781
2,595
1,007
0,903
DENSITY
KG/M3
666,2
658,7
704,9
984,9
1009,8 0,002
0,090
0,083
0,068
0,005
SURFACE TENSION
DYNE/CM
10,5
11,3
15,2
66,7
62,2
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,100
0,102
0,116
0,559
0,437
VISCOSITY
CP
0,2
0,2
0,4
0,5
0,8
Z FACTOR
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
98
DESCRIPTION
RICH AMINE
Rev.
99 REFLUX 011-C-0001
Rev.
TR Project No.: 02020 Page 152 of 193
100 REFLUX 011-C-0002
Rev.
101
Rev.
HVGO TO 011-C-0003
----- TOTAL STREAM ----KG-MOL/HR
355,1
498,4
758,0
1702,0
KG/HR
8122,5
50870,4
79496,0
791941,3
TEMPERATURE
°C
68,2
110,1
64,8
267,2
PRESSURE
BAR(GA)
2,0
3,7
1,0
-0,9
22,9
102,1
104,9
465,3
RATE
MOLECULAR WEIGHT KCAL/KG
-3027,3
-486,8
-506,9
-371,6
KCAL/HR
-2,46E+07
-2,48E+07
-4,03E+07
-2,94E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
KG/HR
-
-
-
-
M3/HR
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
VISCOSITY
CP
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
355,1
498,4
758,0
1702,0
KG/HR
8122,5
50870,4
79496,0
791941,3
M3/HR
8,0
80,9
117,5
1030,4
GAL(US)/MIN
35,1
356,0
517,4
4536,9
M3/HR
MOLECULAR WEIGHT
8,0
71,3
110,8
837,1
22,9
102,1
104,9
465,3 -371,6
ENTHALPY
KCAL/KG
-3027,3
-486,8
-506,9
CP
KCAL/KG-C
0,886
0,614
0,569
0,655
DENSITY
KG/M3
1018,7
629,2
676,5
768,5 0,002
0,002
0,024
0,011
SURFACE TENSION
DYNE/CM
63,2
12,2
16,0
16,9
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,423
0,087
0,096
0,113
VISCOSITY
CP
0,8
0,2
0,3
1,0
Z FACTOR
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
7.
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 153 of 193
KEROSENE IN DIESEL POOL CASE CASE
The heat and material balance for the Kerosene in Diesel Pool Case (LVGO/MVGO cut point maximized) is included in this section. Stream numbers correspond to the streams identified in the Process Flow Diagrams: SA-JER-DS011TRJR-450010, SA-JER-DS010-TRJR-450029, SA-JER-DS011-TRJR-450011, SA-JER-DS011-TRJR-450012, SAJER-DS011-TRJR-450030, SA-JER-DS011-TRJR-450031 and SA-JER-DS011-TRJR-450041.
7.1.
STREAM COMPOSITIONS – KEROSENE IN DIESEL POOL CASE CASE
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
1
DESCRIPTION
CRUDE
Component
REV: 03 Date: 12-MAY-11
Rev.
2 WILD NAPHTHA
Rev.
3 TOTAL NAPHTHA
Rev.
TR Project No.: 02020 Page 154 of 193
4 KEROSENE TO LP HDS
Rev.
5
Rev.
KEROSENE TO STORAGE
Mass Frac (%)
H2O
0,00
0,00
3,03E-02
0,00
0,00
H2S
0,00
0,450
1,66E-02
0,00
0,00
HYDROGEN
0,00
0,00
0,00
0,00
0,00
AIR
0,00
0,00
0,00
0,00
0,00
METHANE
0,00
4,00E-02
6,44E-04
0,00
0,00
ETHANE
2,92E-02
0,520
0,242
0,00
0,00
ETHYLENE
0,00
0,00
0,00
0,00
0,00
PROPANE
0,441
1,73
3,45
0,00
0,00
PROPENE
0,00
0,00
0,00
0,00
0,00
IBUTANE
0,198
1,31
1,58
0,00
0,00
BUTANE
0,879
2,81
6,86
0,00
0,00
1-BUTENE
0,00
0,00
0,00
0,00
0,00
IPENTANE
0,614
2,48
4,83
0,00
0,00
PENTANE
1,12
2,33
8,67
0,00
0,00
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
0,154
5,59
1,48
0,00
0,00 0,00
NBP45*
0,404
3,51
3,28
0,00
NBP55.*
0,458
3,67
3,71
0,00
0,00
NBP65*
0,546
4,06
4,41
0,00
0,00
NBP75*
0,665
4,72
5,36
3,34E-04
3,34E-04
NBP85*
0,796
5,59
6,42
1,97E-03
1,97E-03
NBP95*
0,900
6,71
7,27
1,06E-02
1,06E-02
NBP105*
1,00
7,95
8,08
5,53E-02
5,53E-02
NBP115*
1,09
9,14
8,64
0,250
0,250
NBP125*
1,16
9,77
8,67
0,874
0,874
NBP135*
1,22
7,59
7,77
2,21
2,21
NBP145*
1,26
5,16
5,89
4,50
4,50
NBP155*
1,29
3,87
2,56
8,39
8,39
NBP165*
1,31
3,15
0,652
10,5
10,5
NBP175*
1,32
2,69
0,117
11,0
11,0
NBP185*
1,32
2,00
1,13E-02
10,7
10,7
NBP195*
1,32
1,21
1,46E-03
10,2
10,2
NBP205*
1,32
0,949
1,85E-04
9,61
9,61
NBP215*
1,34
0,956
0,00
8,88
8,88
NBP225*
1,36
3,54E-02
0,00
7,85
7,85
NBP235*
1,39
0,00
0,00
6,50
6,50
NBP245*
1,42
0,00
0,00
4,62
4,62
NBP255*
1,44
0,00
0,00
2,57
2,57
NBP265*
1,46
0,00
0,00
0,990
0,990
NBP275*
1,48
0,00
0,00
0,278
0,278
NBP285*
1,50
0,00
0,00
4,55E-02
4,55E-02
NBP295*
1,51
0,00
0,00
7,65E-03
7,65E-03
NBP305*
1,52
0,00
0,00
1,12E-03
1,12E-03
NBP315*
1,53
0,00
0,00
1,34E-04
1,34E-04
NBP325*
1,54
0,00
0,00
0,00
0,00
NBP335*
1,55
0,00
0,00
0,00
0,00
NBP345*
1,54
0,00
0,00
0,00
0,00
NBP355*
1,53
0,00
0,00
0,00
0,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 155 of 193
STREAM Nº
1
DESCRIPTION
CRUDE
WILD NAPHTHA
TOTAL NAPHTHA
KEROSENE TO LP HDS
KEROSENE TO STORAGE
NBP365*
1,51
0,00
0,00
0,00
0,00
NBP375*
1,47
0,00
0,00
0,00
0,00
NBP385*
1,43
0,00
0,00
0,00
0,00
NBP395*
1,39
0,00
0,00
0,00
0,00
NBP405*
1,36
0,00
0,00
0,00
0,00
NBP415*
1,33
0,00
0,00
0,00
0,00
NBP425*
1,30
0,00
0,00
0,00
0,00
NBP435*
1,28
0,00
0,00
0,00
0,00
NBP445*
1,27
0,00
0,00
0,00
0,00
NBP455*
1,26
0,00
0,00
0,00
0,00
NBP470*
2,51
0,00
0,00
0,00
0,00
NBP490*
2,73
0,00
0,00
0,00
0,00
NBP510*
2,90
0,00
0,00
0,00
0,00
NBP530*
2,81
0,00
0,00
0,00
0,00
NBP550*
4,22
0,00
0,00
0,00
0,00
NBP570*
1,80
0,00
0,00
0,00
0,00
NBP590*
1,75
0,00
0,00
0,00
0,00
NBP610*
1,67
0,00
0,00
0,00
0,00
NBP630*
1,56
0,00
0,00
0,00
0,00
NBP660*
2,88
0,00
0,00
0,00
0,00
NBP700*
2,66
0,00
0,00
0,00
0,00
NBP740*
2,50
0,00
0,00
0,00
0,00
NBP780*
2,39
0,00
0,00
0,00
0,00
NBP820*
2,27
0,00
0,00
0,00
0,00
NBP860*
2,21
0,00
0,00
0,00
0,00
NBP900*
2,21
0,00
0,00
0,00
0,00
NBP940*
2,21
0,00
0,00
0,00
0,00
NBP980*
2,21
0,00
0,00
0,00
0,00
Component
Rev.
2
Rev.
3
Rev.
4
Rev.
5
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
6
DESCRIPTION
Component
REV: 03 Date: 12-MAY-11 Rev.
7
Rev.
8+9
LAGO TO LP HDS
LAGO TO STORAGE
HAGO TO HP HDS/ STORAGE
Rev.
TR Project No.: 02020 Page 156 of 193 10+11
Rev.
12
LVGO TO HP HDS/ STORAGE
HVGO TO DHC/MHC
2,47E-03
Rev.
Mass Frac (%)
H2O
9,63E-02
9,63E-02
7,65E-02
5,70E-03
H2S
0,00
0,00
0,00
0,00
0,00
HYDROGEN
0,00
0,00
0,00
0,00
0,00
AIR
0,00
0,00
0,00
0,00
0,00
METHANE
0,00
0,00
0,00
0,00
0,00
ETHANE
0,00
0,00
0,00
0,00
0,00
ETHYLENE
0,00
0,00
0,00
0,00
0,00
PROPANE
0,00
0,00
0,00
0,00
0,00
PROPENE
0,00
0,00
0,00
0,00
0,00
IBUTANE
0,00
0,00
0,00
0,00
0,00
BUTANE
0,00
0,00
0,00
0,00
0,00
1-BUTENE
0,00
0,00
0,00
0,00
0,00
IPENTANE
0,00
0,00
0,00
0,00
0,00
PENTANE
2,19E-04
2,19E-04
0,00
1,67E-04
0,00
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
0,00
0,00
0,00
0,00
0,00 0,00
NBP45*
1,75E-04
1,75E-04
0,00
0,00
NBP55.*
3,70E-04
3,70E-04
0,00
0,00
0,00
NBP65*
8,00E-04
8,00E-04
1,03E-04
0,00
0,00
NBP75*
1,72E-03
1,72E-03
2,12E-04
0,00
0,00
NBP85*
3,67E-03
3,67E-03
4,21E-04
0,00
0,00
NBP95*
7,38E-03
7,38E-03
7,93E-04
0,00
0,00
NBP105*
1,46E-02
1,46E-02
1,43E-03
0,00
0,00
NBP115*
2,79E-02
2,79E-02
2,46E-03
3,40E-03
1,92E-04
NBP125*
5,23E-02
5,23E-02
4,12E-03
7,60E-03
3,50E-04
NBP135*
9,55E-02
9,55E-02
6,90E-03
1,48E-02
5,50E-04
NBP145*
0,170
0,170
1,18E-02
2,51E-02
7,42E-04
NBP155*
0,313
0,313
2,08E-02
4,83E-02
1,05E-03
NBP165*
0,498
0,498
3,37E-02
8,00E-02
1,37E-03
NBP175*
0,739
0,739
5,24E-02
0,128
1,70E-03
NBP185*
1,10
1,10
8,10E-02
0,190
1,78E-03
NBP195*
1,56
1,56
0,123
0,263
1,90E-03
NBP205*
2,19
2,19
0,187
0,371
2,14E-03
NBP215*
3,04
3,04
0,281
0,488
2,36E-03
NBP225*
4,20
4,20
0,419
0,572
2,46E-03
NBP235*
5,77
5,77
0,615
0,651
2,66E-03
NBP245*
7,86
7,86
0,886
0,754
3,11E-03
NBP255*
10,0
10,0
1,22
0,788
3,40E-03
NBP265*
11,6
11,6
1,66
0,831
3,91E-03
NBP275*
11,9
11,9
2,22
0,986
5,21E-03
NBP285*
11,2
11,2
3,22
1,36
8,76E-03
NBP295*
10,0
10,0
4,46
1,98
1,54E-02
NBP305*
8,16
8,16
6,23
2,91
2,79E-02
NBP315*
5,53
5,53
8,64
4,32
5,20E-02
NBP325*
2,68
2,68
11,1
6,13
9,41E-02
NBP335*
0,860
0,860
12,1
8,36
0,167
NBP345*
0,203
0,203
11,6
10,8
0,286
NBP355*
4,02E-02
4,02E-02
10,3
13,3
0,491
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
6
REV: 03 Date: 12-MAY-11 Rev.
7
Rev.
8+9
Rev.
TR Project No.: 02020 Page 157 of 193 10+11
Rev.
12
LAGO TO LP HDS
LAGO TO STORAGE
HAGO TO HP HDS/ STORAGE
NBP365*
7,06E-03
7,06E-03
8,52
15,2
0,855
NBP375*
1,11E-03
1,11E-03
6,54
15,0
1,59
NBP385*
1,51E-04
1,51E-04
4,50
10,1
3,02
NBP395*
0,00
0,00
2,68
3,50
4,58
NBP405*
0,00
0,00
1,35
0,707
5,34
NBP415*
0,00
0,00
0,587
0,110
5,54
NBP425*
0,00
0,00
0,229
1,53E-02
5,54
NBP435*
0,00
0,00
8,29E-02
1,94E-03
5,48
NBP445*
0,00
0,00
2,83E-02
2,28E-04
5,43
NBP455*
0,00
0,00
9,45E-03
0,00
5,38
NBP470*
0,00
0,00
3,55E-03
0,00
10,7
NBP490*
0,00
0,00
3,39E-04
0,00
11,5
NBP510*
0,00
0,00
0,00
0,00
11,6
NBP530*
0,00
0,00
0,00
0,00
9,05
NBP550*
0,00
0,00
0,00
0,00
9,64
NBP570*
0,00
0,00
0,00
0,00
2,30
NBP590*
0,00
0,00
0,00
0,00
0,898
NBP610*
0,00
0,00
0,00
0,00
0,249
NBP630*
0,00
0,00
0,00
0,00
5,35E-02
NBP660*
0,00
0,00
0,00
0,00
8,76E-03
NBP700*
0,00
0,00
0,00
0,00
2,67E-04
NBP740*
0,00
0,00
0,00
0,00
0,00
NBP780*
0,00
0,00
0,00
0,00
0,00
NBP820*
0,00
0,00
0,00
0,00
0,00
NBP860*
0,00
0,00
0,00
0,00
0,00
NBP900*
0,00
0,00
0,00
0,00
0,00
NBP940*
0,00
0,00
0,00
0,00
0,00
NBP980*
0,00
0,00
0,00
0,00
0,00
DESCRIPTION
Component
LVGO TO HP HDS/ STORAGE
HVGO TO DHC/MHC
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
13
REV: 03 Date: 12-MAY-11 Rev.
14
Rev.
15
Rev.
TR Project No.: 02020 Page 158 of 193 16
Rev.
17
HVGO TO STORAGE
VAC.RESIDUE TO STORAGE
VAC. RESIDUE TO DCU
PREFLASH OVERHEAD
NAPHTHA FROM PREFLASH
H2O
2,47E-03
2,03E-03
2,03E-03
9,13
11,7
H2S
0,00
0,00
0,00
0,00
0,00
HYDROGEN
0,00
0,00
0,00
0,00
0,00
DESCRIPTION
Component
Rev.
Mass Frac (%)
AIR
0,00
0,00
0,00
0,00
0,00
METHANE
0,00
0,00
0,00
0,00
0,00
ETHANE
0,00
0,00
0,00
0,244
0,383
ETHYLENE
0,00
0,00
0,00
0,00
0,00
PROPANE
0,00
0,00
0,00
3,65
5,64
PROPENE
0,00
0,00
0,00
0,00
0,00
IBUTANE
0,00
0,00
0,00
1,60
2,40
BUTANE
0,00
0,00
0,00
7,04
10,4
1-BUTENE
0,00
0,00
0,00
0,00
0,00
IPENTANE
0,00
0,00
0,00
4,68
6,49
PENTANE
0,00
0,00
0,00
8,48
11,5
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
0,00
0,00
0,00
1,16
1,55 3,89
NBP45*
0,00
0,00
0,00
2,99
NBP55.*
0,00
0,00
0,00
3,32
4,12
NBP65*
0,00
0,00
0,00
3,87
4,53
NBP75*
0,00
0,00
0,00
4,62
5,04
NBP85*
0,00
0,00
0,00
5,42
5,42
NBP95*
0,00
0,00
0,00
6,02
5,43
NBP105*
0,00
0,00
0,00
6,58
5,26
NBP115*
1,92E-04
0,00
0,00
7,01
4,86
NBP125*
3,50E-04
0,00
0,00
7,23
4,27
NBP135*
5,50E-04
0,00
0,00
7,09
3,49
NBP145*
7,42E-04
0,00
0,00
6,11
2,48
NBP155*
1,05E-03
0,00
0,00
2,96
0,931
NBP165*
1,37E-03
0,00
0,00
0,689
0,174
NBP175*
1,70E-03
0,00
0,00
0,102
2,04E-02
NBP185*
1,78E-03
0,00
0,00
7,63E-03
1,10E-03
NBP195*
1,90E-03
0,00
0,00
7,61E-04
0,00
NBP205*
2,14E-03
0,00
0,00
0,00
0,00
NBP215*
2,36E-03
0,00
0,00
0,00
0,00
NBP225*
2,46E-03
0,00
0,00
0,00
0,00
NBP235*
2,66E-03
0,00
0,00
0,00
0,00
NBP245*
3,11E-03
0,00
0,00
0,00
0,00
NBP255*
3,40E-03
0,00
0,00
0,00
0,00
NBP265*
3,91E-03
0,00
0,00
0,00
0,00
NBP275*
5,21E-03
0,00
0,00
0,00
0,00
NBP285*
8,76E-03
0,00
0,00
0,00
0,00
NBP295*
1,54E-02
0,00
0,00
0,00
0,00
NBP305*
2,79E-02
0,00
0,00
0,00
0,00
NBP315*
5,20E-02
0,00
0,00
0,00
0,00
NBP325*
9,41E-02
0,00
0,00
0,00
0,00
NBP335*
0,167
0,00
0,00
0,00
0,00
NBP345*
0,286
0,00
0,00
0,00
0,00
NBP355*
0,491
0,00
0,00
0,00
0,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 159 of 193
STREAM Nº
13
DESCRIPTION
HVGO TO STORAGE
VAC.RESIDUE TO STORAGE
VAC. RESIDUE TO DCU
PREFLASH OVERHEAD
NAPHTHA FROM PREFLASH
NBP365*
0,855
0,00
0,00
0,00
0,00
NBP375*
1,59
0,00
0,00
0,00
0,00
NBP385*
3,02
0,00
0,00
0,00
0,00
NBP395*
4,58
0,00
0,00
0,00
0,00
NBP405*
5,34
1,73E-04
1,73E-04
0,00
0,00
NBP415*
5,54
3,64E-04
3,64E-04
0,00
0,00
NBP425*
5,54
7,52E-04
7,52E-04
0,00
0,00
NBP435*
5,48
1,55E-03
1,55E-03
0,00
0,00
NBP445*
5,43
3,18E-03
3,18E-03
0,00
0,00
NBP455*
5,38
6,55E-03
6,55E-03
0,00
0,00
NBP470*
10,7
3,87E-02
3,87E-02
0,00
0,00
NBP490*
11,5
0,169
0,169
0,00
0,00
NBP510*
11,6
0,625
0,625
0,00
0,00
NBP530*
9,05
2,37
2,37
0,00
0,00
NBP550*
9,64
6,67
6,67
0,00
0,00
NBP570*
2,30
4,28
4,28
0,00
0,00
NBP590*
0,898
5,20
5,20
0,00
0,00
Component
Rev.
14
Rev.
15
Rev.
16
Rev.
17
Rev.
Mass Frac (%)
NBP610*
0,249
5,45
5,45
0,00
0,00
NBP630*
5,35E-02
5,23
5,23
0,00
0,00
NBP660*
8,76E-03
9,73
9,73
0,00
0,00
NBP700*
2,67E-04
8,97
8,97
0,00
0,00
NBP740*
0,00
8,45
8,45
0,00
0,00
NBP780*
0,00
8,07
8,07
0,00
0,00
NBP820*
0,00
7,65
7,65
0,00
0,00
NBP860*
0,00
7,47
7,47
0,00
0,00
NBP900*
0,00
7,47
7,47
0,00
0,00
NBP940*
0,00
7,47
7,47
0,00
0,00
NBP980*
0,00
4,70
4,70
0,00
0,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
18
DESCRIPTION
TOPPED CRUDE
Component
REV: 03 Date: 12-MAY-11 Rev.
19
Rev.
20
CDU OVERHEAD
ATM. RESIDUE
TR Project No.: 02020 Page 160 of 193 Rev.
21 VDU OVERHEAD
Rev.
22
Rev.
RECOVERED OIL
Mass Frac (%)
H2O
0,139
13,1
4,41E-02
75,6
2,40E-02
H2S
0,00
3,61E-02
0,00
0,408
2,57E-02
HYDROGEN
0,00
0,00
0,00
5,11E-03
0,00
AIR
0,00
0,00
0,00
0,128
9,06E-04
METHANE
0,00
2,37E-03
0,00
0,181
2,03E-03
ETHANE
2,72E-04
4,27E-02
0,00
0,170
7,80E-03 1,12E-03
ETHYLENE
0,00
0,00
0,00
3,21E-02
PROPANE
1,61E-02
0,336
0,00
0,236
3,31E-02
PROPENE
0,00
0,00
0,00
9,11E-02
1,11E-02
IBUTANE
1,84E-02
0,346
0,00
5,70E-02
1,89E-02
BUTANE
9,72E-02
1,46
0,00
0,273
0,120
1-BUTENE
0,00
0,00
0,00
0,103
4,01E-02
IPENTANE
0,132
1,91
0,00
0,147
0,141
PENTANE
0,263
3,55
0,00
0,233
0,273
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
3,97E-02
1,05
0,00
0,00
0,00 2,47E-04
NBP45*
0,118
1,83
0,00
1,62E-04
NBP55.*
0,157
2,36
0,00
5,38E-02
0,104
NBP65*
0,218
3,17
0,00
4,59E-02
0,109
NBP75*
0,304
4,35
0,00
4,02E-02
0,115
NBP85*
0,413
5,83
0,00
3,36E-02
0,111
NBP95*
0,524
7,34
0,00
2,71E-02
0,101
NBP105*
0,647
8,96
0,00
2,21E-02
8,94E-02
NBP115*
0,772
10,4
0,00
0,629
2,67
NBP125*
0,897
11,0
0,00
1,02
4,45
NBP135*
1,02
10,2
1,21E-04
1,41
6,25
NBP145*
1,14
7,93
1,92E-04
1,66
7,42
NBP155*
1,30
3,60
3,06E-04
2,03
9,08
NBP165*
1,39
0,983
4,53E-04
2,26
10,1
NBP175*
1,41
0,188
6,54E-04
2,38
10,7
NBP185*
1,41
1,90E-02
9,59E-04
2,03
9,06
NBP195*
1,41
2,52E-03
1,42E-03
1,74
7,76
NBP205*
1,42
3,24E-04
2,16E-03
1,51
6,77
NBP215*
1,43
0,00
3,35E-03
1,24
5,52
NBP225*
1,45
0,00
5,30E-03
0,906
4,05
NBP235*
1,48
0,00
8,53E-03
0,656
2,94
NBP245*
1,51
0,00
1,38E-02
0,491
2,20
NBP255*
1,54
0,00
2,11E-02
0,338
1,51
NBP265*
1,57
0,00
3,24E-02
0,237
1,06
NBP275*
1,58
0,00
4,86E-02
0,188
0,839
NBP285*
1,60
0,00
8,40E-02
0,171
0,763
NBP295*
1,62
0,00
0,133
0,167
0,746
NBP305*
1,63
0,00
0,204
0,166
0,744
NBP315*
1,64
0,00
0,303
0,168
0,752
NBP325*
1,65
0,00
0,433
0,163
0,730
NBP335*
1,65
0,00
0,598
0,153
0,683
NBP345*
1,65
0,00
0,795
0,135
0,603
NBP355*
1,64
0,00
1,02
0,114
0,509
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 161 of 193
STREAM Nº
18
DESCRIPTION
TOPPED CRUDE
CDU OVERHEAD
ATM. RESIDUE
VDU OVERHEAD
RECOVERED OIL
NBP365*
1,61
0,00
1,26
8,86E-02
0,396
NBP375*
1,57
0,00
1,52
5,92E-02
0,265
NBP385*
1,53
0,00
1,78
2,70E-02
0,121
NBP395*
1,49
0,00
2,01
6,29E-03
2,81E-02
NBP405*
1,46
0,00
2,17
8,50E-04
3,80E-03
NBP415*
1,42
0,00
2,24
0,00
3,94E-04
NBP425*
1,40
0,00
2,25
0,00
0,00
NBP435*
1,37
0,00
2,24
0,00
0,00
NBP445*
1,36
0,00
2,22
0,00
0,00
NBP455*
1,34
0,00
2,20
0,00
0,00
NBP470*
2,69
0,00
4,41
0,00
0,00
NBP490*
2,92
0,00
4,79
0,00
0,00
NBP510*
3,10
0,00
5,09
0,00
0,00
NBP530*
3,01
0,00
4,93
0,00
0,00
NBP550*
4,52
0,00
7,41
0,00
0,00
NBP570*
1,93
0,00
3,16
0,00
0,00
NBP590*
1,87
0,00
3,07
0,00
0,00
NBP610*
1,79
0,00
2,93
0,00
0,00
NBP630*
1,67
0,00
2,74
0,00
0,00
NBP660*
3,08
0,00
5,06
0,00
0,00
NBP700*
2,84
0,00
4,66
0,00
0,00
NBP740*
2,68
0,00
4,39
0,00
0,00
NBP780*
2,56
0,00
4,19
0,00
0,00
NBP820*
2,42
0,00
3,98
0,00
0,00
NBP860*
2,37
0,00
3,88
0,00
0,00
NBP900*
2,37
0,00
3,88
0,00
0,00
NBP940*
2,37
0,00
3,88
0,00
0,00
NBP980*
2,37
0,00
3,88
0,00
0,00
Component
Rev.
19
Rev.
20
Rev.
21
Rev.
22
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
23
DESCRIPTION
OFF GAS
Component
REV: 03 Date: 12-MAY-11 Rev.
24
Rev.
25
WASHED OFF GAS
HAGO+LVGO TO HP HDS
Rev.
TR Project No.: 02020 Page 162 of 193 36
Rev.
51
011-G-0002 A/B
HAGO PA TO 011-G-0012 A/B
DESALTED CRUDE TO
Rev.
Mass Frac (%)
H2O
4,48
4,26
5,56E-02
0,832
2,90E-02
H2S
16,0
2,08E-02
1,27E-03
0,00
0,00
HYDROGEN
0,202
0,293
0,00
0,00
0,00
AIR
5,03
7,32
0,00
0,00
0,00
METHANE
7,13
10,4
1,01E-04
0,00
0,00
ETHANE
6,65
9,64
3,85E-04
2,90E-02
0,00
ETHYLENE
1,26
1,83
0,00
0,00
0,00 3,83E-04
PROPANE
9,15
13,1
1,63E-03
0,437
PROPENE
3,54
5,08
5,46E-04
0,00
0,00
IBUTANE
2,16
3,03
9,30E-04
0,197
6,24E-04 3,47E-03
BUTANE
10,2
14,1
5,88E-03
0,872
1-BUTENE
3,87
5,40
1,97E-03
0,00
0,00
IPENTANE
5,09
6,64
6,96E-03
0,609
6,77E-03
PENTANE
7,77
9,86
1,34E-02
1,11
1,40E-02
DEA
0,00
2,30E-04
0,00
0,00
0,00
NBP38*
0,00
0,00
0,00
0,153
2,24E-03
NBP45*
5,07E-03
6,15E-03
0,00
0,401
7,17E-03
NBP55.*
1,55
1,77
5,12E-03
0,454
1,07E-02
NBP65*
1,18
1,24
5,43E-03
0,541
1,65E-02
NBP75*
0,890
0,843
5,78E-03
0,659
2,56E-02
NBP85*
0,606
0,504
5,76E-03
0,789
3,87E-02
NBP95*
0,372
0,263
5,51E-03
0,893
5,47E-02
NBP105*
0,213
0,124
5,38E-03
0,994
7,51E-02
NBP115*
3,88
1,79
0,133
1,08
9,97E-02
NBP125*
3,64
1,31
0,223
1,15
0,129
NBP135*
2,62
0,715
0,314
1,21
0,164
NBP145*
1,50
0,308
0,378
1,25
0,208
NBP155*
0,637
8,94E-02
0,471
1,28
0,273
NBP165*
0,276
2,83E-02
0,538
1,30
0,333
NBP175*
0,106
0,00
0,591
1,31
0,391
NBP185*
1,93E-02
0,00
0,548
1,31
0,459
NBP195*
4,48E-03
0,00
0,533
1,31
0,540
NBP205*
1,00E-03
0,00
0,557
1,31
0,644
NBP215*
2,02E-04
0,00
0,591
1,33
0,779
NBP225*
0,00
0,00
0,636
1,35
0,955
NBP235*
0,00
0,00
0,738
1,38
1,18
NBP245*
0,00
0,00
0,916
1,40
1,48
NBP255*
0,00
0,00
1,12
1,43
1,82
NBP265*
0,00
0,00
1,42
1,45
2,25
NBP275*
0,00
0,00
1,84
1,47
2,77
NBP285*
0,00
0,00
2,62
1,48
3,67
NBP295*
0,00
0,00
3,64
1,50
4,78
NBP305*
0,00
0,00
5,10
1,51
6,34
NBP315*
0,00
0,00
7,14
1,52
8,44
NBP325*
0,00
0,00
9,28
1,53
10,4
NBP335*
0,00
0,00
10,6
1,53
11,1
NBP345*
0,00
0,00
10,8
1,53
10,4
NBP355*
0,00
0,00
10,6
1,52
9,05
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
23 OFF GAS
DESCRIPTION
Component
REV: 03 Date: 12-MAY-11 Rev.
24
Rev.
25
WASHED OFF GAS
HAGO+LVGO TO HP HDS
Rev.
TR Project No.: 02020 Page 163 of 193 36 DESALTED CRUDE TO
Rev.
51
011-G-0002 A/B
HAGO PA TO 011-G-0012 A/B
Rev.
Mass Frac (%)
NBP365*
0,00
0,00
9,85
1,49
7,40
NBP375*
0,00
0,00
8,41
1,46
5,61
NBP385*
0,00
0,00
5,73
1,42
3,82
NBP395*
0,00
0,00
2,76
1,38
2,26
NBP405*
0,00
0,00
1,12
1,35
1,13
NBP415*
0,00
0,00
0,435
1,32
0,489
NBP425*
0,00
0,00
0,162
1,29
0,190
NBP435*
0,00
0,00
5,80E-02
1,27
6,86E-02
NBP445*
0,00
0,00
1,96E-02
1,26
2,33E-02
NBP455*
0,00
0,00
6,55E-03
1,24
7,77E-03
NBP470*
0,00
0,00
2,46E-03
2,49
2,91E-03
NBP490*
0,00
0,00
2,35E-04
2,71
2,77E-04
NBP510*
0,00
0,00
0,00
2,87
0,00
NBP530*
0,00
0,00
0,00
2,79
0,00
NBP550*
0,00
0,00
0,00
4,19
0,00
NBP570*
0,00
0,00
0,00
1,79
0,00
NBP590*
0,00
0,00
0,00
1,73
0,00
NBP610*
0,00
0,00
0,00
1,66
0,00
NBP630*
0,00
0,00
0,00
1,55
0,00
NBP660*
0,00
0,00
0,00
2,86
0,00
NBP700*
0,00
0,00
0,00
2,64
0,00
NBP740*
0,00
0,00
0,00
2,48
0,00
NBP780*
0,00
0,00
0,00
2,37
0,00
NBP820*
0,00
0,00
0,00
2,25
0,00
NBP860*
0,00
0,00
0,00
2,19
0,00
NBP900*
0,00
0,00
0,00
2,19
0,00
NBP940*
0,00
0,00
0,00
2,19
0,00
NBP980*
0,00
0,00
0,00
2,19
0,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
53
DESCRIPTION
HAGO TO 011-C-0006
Component
REV: 03 Date: 12-MAY-11 Rev.
54
Rev.
59
TR Project No.: 02020 Page 164 of 193 Rev.
61
Rev.
62
HAGO TO 011-G-0013 A/B
LAGO PA TO 011-G-0010 A/B
LAGO TO 011-C-0005
LAGO TO 011-G-0011 A/B
9,63E-02
Rev.
Mass Frac (%)
H2O
2,90E-02
7,65E-02
4,53E-02
4,53E-02
H2S
0,00
0,00
0,00
0,00
0,00
HYDROGEN
0,00
0,00
0,00
0,00
0,00
AIR
0,00
0,00
0,00
0,00
0,00
METHANE
0,00
0,00
0,00
0,00
0,00 0,00
ETHANE
0,00
0,00
0,00
0,00
ETHYLENE
0,00
0,00
0,00
0,00
0,00
PROPANE
3,83E-04
0,00
5,94E-04
5,94E-04
0,00
PROPENE
0,00
0,00
0,00
0,00
0,00
IBUTANE
6,24E-04
0,00
1,04E-03
1,04E-03
0,00 0,00
BUTANE
3,47E-03
0,00
5,93E-03
5,93E-03
1-BUTENE
0,00
0,00
0,00
0,00
0,00
IPENTANE
6,77E-03
0,00
1,23E-02
1,23E-02
0,00
PENTANE
1,40E-02
0,00
2,58E-02
2,58E-02
2,19E-04
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
2,24E-03
0,00
4,17E-03
4,17E-03
0,00
NBP45*
7,17E-03
0,00
1,35E-02
1,35E-02
1,75E-04
NBP55.*
1,07E-02
0,00
2,06E-02
2,06E-02
3,70E-04
NBP65*
1,65E-02
1,03E-04
3,24E-02
3,24E-02
8,00E-04
NBP75*
2,56E-02
2,12E-04
5,14E-02
5,14E-02
1,72E-03
NBP85*
3,87E-02
4,21E-04
7,98E-02
7,98E-02
3,67E-03
NBP95*
5,47E-02
7,93E-04
0,117
0,117
7,38E-03
NBP105*
7,51E-02
1,43E-03
0,168
0,168
1,46E-02
NBP115*
9,97E-02
2,46E-03
0,235
0,235
2,79E-02
NBP125*
0,129
4,12E-03
0,324
0,324
5,23E-02
NBP135*
0,164
6,90E-03
0,442
0,442
9,55E-02
NBP145*
0,208
1,18E-02
0,602
0,602
0,170
NBP155*
0,273
2,08E-02
0,852
0,852
0,313
NBP165*
0,333
3,37E-02
1,11
1,11
0,498
NBP175*
0,391
5,24E-02
1,38
1,38
0,739
NBP185*
0,459
8,10E-02
1,76
1,76
1,10
NBP195*
0,540
0,123
2,20
2,20
1,56
NBP205*
0,644
0,187
2,79
2,79
2,19
NBP215*
0,779
0,281
3,57
3,57
3,04
NBP225*
0,955
0,419
4,61
4,61
4,20
NBP235*
1,18
0,615
6,01
6,01
5,77
NBP245*
1,48
0,886
7,84
7,84
7,86
NBP255*
1,82
1,22
9,69
9,69
10,0
NBP265*
2,25
1,66
10,9
10,9
11,6
NBP275*
2,77
2,22
11,0
11,0
11,9
NBP285*
3,67
3,22
10,1
10,1
11,2
NBP295*
4,78
4,46
8,89
8,89
10,0
NBP305*
6,34
6,23
7,15
7,15
8,16
NBP315*
8,44
8,64
4,79
4,79
5,53
NBP325*
10,4
11,1
2,31
2,31
2,68
NBP335*
11,1
12,1
0,735
0,735
0,860
NBP345*
10,4
11,6
0,173
0,173
0,203
NBP355*
9,05
10,3
3,41E-02
3,41E-02
4,02E-02
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
53
DESCRIPTION
HAGO TO 011-C-0006
NBP365* NBP375*
REV: 03 Date: 12-MAY-11 Rev.
54
Rev.
59
TR Project No.: 02020 Page 165 of 193 Rev.
61
Rev.
62
HAGO TO 011-G-0013 A/B
LAGO PA TO 011-G-0010 A/B
LAGO TO 011-C-0005
LAGO TO 011-G-0011 A/B
7,40
8,52
5,97E-03
5,97E-03
7,06E-03
5,61
6,54
9,33E-04
9,33E-04
1,11E-03
NBP385*
3,82
4,50
1,28E-04
1,28E-04
1,51E-04
NBP395*
2,26
2,68
0,00
0,00
0,00
NBP405*
1,13
1,35
0,00
0,00
0,00
NBP415*
0,489
0,587
0,00
0,00
0,00
Component
Rev.
Mass Frac (%)
NBP425*
0,190
0,229
0,00
0,00
0,00
NBP435*
6,86E-02
8,29E-02
0,00
0,00
0,00
NBP445*
2,33E-02
2,83E-02
0,00
0,00
0,00
NBP455*
7,77E-03
9,45E-03
0,00
0,00
0,00
NBP470*
2,91E-03
3,55E-03
0,00
0,00
0,00
NBP490*
2,77E-04
3,39E-04
0,00
0,00
0,00
NBP510*
0,00
0,00
0,00
0,00
0,00
NBP530*
0,00
0,00
0,00
0,00
0,00
NBP550*
0,00
0,00
0,00
0,00
0,00
NBP570*
0,00
0,00
0,00
0,00
0,00
NBP590*
0,00
0,00
0,00
0,00
0,00
NBP610*
0,00
0,00
0,00
0,00
0,00
NBP630*
0,00
0,00
0,00
0,00
0,00
NBP660*
0,00
0,00
0,00
0,00
0,00
NBP700*
0,00
0,00
0,00
0,00
0,00
NBP740*
0,00
0,00
0,00
0,00
0,00
NBP780*
0,00
0,00
0,00
0,00
0,00
NBP820*
0,00
0,00
0,00
0,00
0,00
NBP860*
0,00
0,00
0,00
0,00
0,00
NBP900*
0,00
0,00
0,00
0,00
0,00
NBP940*
0,00
0,00
0,00
0,00
0,00
NBP980*
0,00
0,00
0,00
0,00
0,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
67
DESCRIPTION
KERO PA TO
Component
REV: 03 Date: 12-MAY-11 Rev.
69
011-G-0008 A/B
KERO TO 011-C-0005
Rev.
70 KERO TO 011-G-0009 A/B
TR Project No.: 02020 Page 166 of 193 Rev.
75
77 (1)
NAPHTHA TO 011-E-0021
ATM. RESIDUE TO 011-C-0003
Rev.
Mass Frac (%)
H2O
8,60E-02
8,60E-02
0,00
6,39
1,23
H2S
0,00
0,00
0,00
1,55E-02
2,06E-02
HYDROGEN
0,00
0,00
0,00
0,00
2,58E-04
AIR
0,00
0,00
0,00
0,00
6,44E-03
METHANE
0,00
0,00
0,00
6,03E-04
9,13E-03 8,56E-03
ETHANE
0,00
0,00
0,00
0,226
ETHYLENE
0,00
0,00
0,00
0,00
1,62E-03
PROPANE
1,37E-03
1,37E-03
0,00
3,23
1,19E-02
PROPENE
0,00
0,00
0,00
0,00
4,60E-03
IBUTANE
2,68E-03
2,68E-03
0,00
1,48
2,88E-03 1,38E-02
BUTANE
1,54E-02
1,54E-02
0,00
6,42
1-BUTENE
0,00
0,00
0,00
0,00
5,21E-03
IPENTANE
3,61E-02
3,61E-02
0,00
4,52
7,44E-03
PENTANE
7,77E-02
7,77E-02
0,00
8,12
1,18E-02
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
1,64E-02
1,64E-02
0,00
1,39
0,00
NBP45*
4,62E-02
4,62E-02
0,00
3,08
0,00
NBP55.*
7,52E-02
7,52E-02
0,00
3,47
2,72E-03
NBP65*
0,129
0,129
0,00
4,13
2,32E-03
NBP75*
0,224
0,224
3,34E-04
5,02
2,04E-03
NBP85*
0,384
0,384
1,97E-03
6,01
1,70E-03
NBP95*
0,622
0,622
1,06E-02
6,81
1,37E-03
NBP105*
0,996
0,996
5,53E-02
7,57
1,12E-03
NBP115*
1,57
1,57
0,250
8,09
3,20E-02
NBP125*
2,44
2,44
0,874
8,11
5,20E-02
NBP135*
3,74
3,74
2,21
7,28
7,22E-02
NBP145*
5,80
5,80
4,50
5,52
8,57E-02
NBP155*
9,19
9,19
8,39
2,40
0,106
NBP165*
10,6
10,6
10,5
0,610
0,119
NBP175*
10,4
10,4
11,0
0,110
0,129
NBP185*
9,71
9,71
10,7
1,06E-02
0,114
NBP195*
8,99
8,99
10,2
1,37E-03
0,104
NBP205*
8,30
8,30
9,61
1,73E-04
9,93E-02
NBP215*
7,54
7,54
8,88
0,00
9,23E-02
NBP225*
6,58
6,58
7,85
0,00
8,08E-02
NBP235*
5,40
5,40
6,50
0,00
7,30E-02
NBP245*
3,81
3,81
4,62
0,00
7,10E-02
NBP255*
2,11
2,11
2,57
0,00
6,53E-02
NBP265*
0,808
0,808
0,990
0,00
6,30E-02
NBP275*
0,226
0,226
0,278
0,00
7,03E-02
NBP285*
3,69E-02
3,69E-02
4,55E-02
0,00
9,34E-02
NBP295*
6,19E-03
6,19E-03
7,65E-03
0,00
0,133
NBP305*
9,08E-04
9,08E-04
1,12E-03
0,00
0,193
NBP315*
1,08E-04
1,08E-04
1,34E-04
0,00
0,287
NBP325*
0,00
0,00
0,00
0,00
0,411
NBP335*
0,00
0,00
0,00
0,00
0,573
NBP345*
0,00
0,00
0,00
0,00
0,765
NBP355*
0,00
0,00
0,00
0,00
0,997
NOTES: (1) Cracking in the vacuum heater has been considered.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
STREAM Nº
67 KERO PA TO
REV: 03 Date: 12-MAY-11
Rev.
69
Rev.
70
Rev.
TR Project No.: 02020 Page 167 of 193
75
77 (1)
011-G-0009 A/B
NAPHTHA TO 011-E-0021
ATM. RESIDUE TO 011-C-0003
011-G-0008 A/B
KERO TO 011-C-0005
NBP365*
0,00
0,00
0,00
0,00
1,26
NBP375*
0,00
0,00
0,00
0,00
1,54
NBP385*
0,00
0,00
0,00
0,00
1,82
NBP395*
0,00
0,00
0,00
0,00
2,06
NBP405*
0,00
0,00
0,00
0,00
2,20
NBP415*
0,00
0,00
0,00
0,00
2,24
NBP425*
0,00
0,00
0,00
0,00
2,24
NBP435*
0,00
0,00
0,00
0,00
2,21
NBP445*
0,00
0,00
0,00
0,00
2,19
NBP455*
0,00
0,00
0,00
0,00
2,17
NBP470*
0,00
0,00
0,00
0,00
4,35
NBP490*
0,00
0,00
0,00
0,00
4,73
NBP510*
0,00
0,00
0,00
0,00
5,02
NBP530*
0,00
0,00
0,00
0,00
4,87
NBP550*
0,00
0,00
0,00
0,00
7,31
NBP570*
0,00
0,00
0,00
0,00
3,12
NBP590*
0,00
0,00
0,00
0,00
3,02
NBP610*
0,00
0,00
0,00
0,00
2,89
NBP630*
0,00
0,00
0,00
0,00
2,70
NBP660*
0,00
0,00
0,00
0,00
4,98
NBP700*
0,00
0,00
0,00
0,00
4,59
NBP740*
0,00
0,00
0,00
0,00
4,33
NBP780*
0,00
0,00
0,00
0,00
4,13
NBP820*
0,00
0,00
0,00
0,00
3,92
NBP860*
0,00
0,00
0,00
0,00
3,82
NBP900*
0,00
0,00
0,00
0,00
3,82
NBP940*
0,00
0,00
0,00
0,00
3,82
NBP980*
0,00
0,00
0,00
0,00
2,41
DESCRIPTION
Component
KERO TO
Rev.
Mass Frac (%)
NOTES: (1) Cracking in the vacuum heater has been considered.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
78
REV: 03 Date: 12-MAY-11 81
Rev.
84
85
87
VAC. RESIDUE
DESCRIPTION
Component
TR Project No.: 02020 Page 168 of 193
TO 011-G-0018 A/B
HVGO TO 011-G-0017 A/B
MVGO TO 011-G-0016 A/B
MVGO + HVGO TO 011-E-0015 A/B
LVGO TO 011-G-0015 A/B
5,70E-03
Rev.
Mass Frac (%)
H2O
2,03E-03
2,11E-03
3,07E-03
2,47E-03
H2S
0,00
0,00
0,00
0,00
0,00
HYDROGEN
0,00
0,00
0,00
0,00
0,00
AIR
0,00
0,00
0,00
0,00
0,00
METHANE
0,00
0,00
0,00
0,00
0,00
ETHANE
0,00
0,00
0,00
0,00
0,00
ETHYLENE
0,00
0,00
0,00
0,00
0,00
PROPANE
0,00
0,00
0,00
0,00
0,00
PROPENE
0,00
0,00
0,00
0,00
0,00
IBUTANE
0,00
0,00
0,00
0,00
0,00
BUTANE
0,00
0,00
0,00
0,00
0,00
1-BUTENE
0,00
0,00
0,00
0,00
0,00
IPENTANE
0,00
0,00
0,00
0,00
0,00
PENTANE
0,00
0,00
0,00
0,00
1,67E-04
DEA
0,00
0,00
0,00
0,00
0,00
NBP38*
0,00
0,00
0,00
0,00
0,00
NBP45*
0,00
0,00
0,00
0,00
0,00
NBP55.*
0,00
0,00
0,00
0,00
0,00
NBP65*
0,00
0,00
0,00
0,00
0,00
NBP75*
0,00
0,00
0,00
0,00
0,00
NBP85*
0,00
0,00
0,00
0,00
0,00
NBP95*
0,00
0,00
0,00
0,00
0,00
NBP105*
0,00
0,00
0,00
0,00
0,00
NBP115*
0,00
1,40E-04
2,77E-04
1,92E-04
3,40E-03
NBP125*
0,00
2,50E-04
5,15E-04
3,50E-04
7,60E-03
NBP135*
0,00
3,84E-04
8,24E-04
5,50E-04
1,48E-02
NBP145*
0,00
5,04E-04
1,14E-03
7,42E-04
2,51E-02
NBP155*
0,00
6,95E-04
1,65E-03
1,05E-03
4,83E-02
NBP165*
0,00
8,79E-04
2,17E-03
1,37E-03
8,00E-02
NBP175*
0,00
1,07E-03
2,75E-03
1,70E-03
0,128
NBP185*
0,00
1,09E-03
2,92E-03
1,78E-03
0,190
NBP195*
0,00
1,13E-03
3,16E-03
1,90E-03
0,263
NBP205*
0,00
1,25E-03
3,62E-03
2,14E-03
0,371
NBP215*
0,00
1,34E-03
4,04E-03
2,36E-03
0,488
NBP225*
0,00
1,37E-03
4,27E-03
2,46E-03
0,572
NBP235*
0,00
1,45E-03
4,67E-03
2,66E-03
0,651
NBP245*
0,00
1,66E-03
5,52E-03
3,11E-03
0,754
NBP255*
0,00
1,77E-03
6,09E-03
3,40E-03
0,788
NBP265*
0,00
2,00E-03
7,08E-03
3,91E-03
0,831
NBP275*
0,00
2,60E-03
9,52E-03
5,21E-03
0,986
NBP285*
0,00
4,30E-03
1,61E-02
8,76E-03
1,36
NBP295*
0,00
7,43E-03
2,86E-02
1,54E-02
1,98
NBP305*
0,00
1,32E-02
5,22E-02
2,79E-02
2,91
NBP315*
0,00
2,42E-02
9,78E-02
5,20E-02
4,32
NBP325*
0,00
4,32E-02
0,178
9,41E-02
6,13
NBP335*
0,00
7,51E-02
0,318
0,167
8,36
NBP345*
0,00
0,126
0,551
0,286
10,8
NBP355*
0,00
0,209
0,958
0,491
13,3
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
78
REV: 03 Date: 12-MAY-11 81
Rev.
TR Project No.: 02020 Page 169 of 193
84
85
87
VAC. RESIDUE
TO 011-G-0018 A/B
HVGO TO 011-G-0017 A/B
MVGO TO 011-G-0016 A/B
MVGO + HVGO TO 011-E-0015 A/B
LVGO TO 011-G-0015 A/B
NBP365*
0,00
0,338
1,71
0,855
15,2
NBP375*
0,00
0,537
3,33
1,59
15,0
NBP385*
0,00
0,842
6,62
3,02
10,1
NBP395*
0,00
1,26
10,1
4,58
3,50
NBP405*
1,73E-04
1,75
11,3
5,34
0,707
NBP415*
3,64E-04
2,28
10,9
5,54
0,110
NBP425*
7,52E-04
2,85
10,0
5,54
1,53E-02
NBP435*
1,55E-03
3,46
8,82
5,48
1,94E-03
NBP445*
3,18E-03
4,12
7,61
5,43
2,28E-04
NBP455*
6,55E-03
4,77
6,38
5,38
0,00
NBP470*
3,87E-02
11,5
9,45
10,7
0,00
NBP490*
0,169
14,7
6,26
11,5
0,00
NBP510*
0,625
16,5
3,63
11,6
0,00
NBP530*
2,37
13,9
0,985
9,05
0,00
NBP550*
6,67
15,1
0,570
9,64
0,00
NBP570*
4,28
3,64
7,30E-02
2,30
0,00
NBP590*
5,20
1,43
1,53E-02
0,898
0,00
NBP610*
5,45
0,398
2,25E-03
0,249
0,00
NBP630*
5,23
8,58E-02
2,55E-04
5,35E-02
0,00
NBP660*
9,73
1,40E-02
0,00
8,76E-03
0,00
NBP700*
8,97
4,28E-04
0,00
2,67E-04
0,00
NBP740*
8,45
0,00
0,00
0,00
0,00
NBP780*
8,07
0,00
0,00
0,00
0,00
NBP820*
7,65
0,00
0,00
0,00
0,00
NBP860*
7,47
0,00
0,00
0,00
0,00
NBP900*
7,47
0,00
0,00
0,00
0,00
NBP940*
7,47
0,00
0,00
0,00
0,00
NBP980*
4,70
0,00
0,00
0,00
0,00
DESCRIPTION
Component
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
90
DESCRIPTION
OFF GAS TO 011-C-0007
BRINE TO WWT
SOUR WATER TO SWS
Component
Rev.
91 (1)
Rev.
96 (2)
TR Project No.: 02020 Page 170 of 193 Rev.
97
Rev.
98
LEAN AMINE
RICH AMINE
Rev.
Mass Frac (%)
H2O
1,28
100,0
100,0
74,9
73,5
H2S
19,2
0,00
0,00
0,162
1,86
HYDROGEN
0,244
0,00
0,00
0,00
0,00
AIR
6,08
0,00
0,00
0,00
3,34E-04
METHANE
8,62
0,00
0,00
0,00
9,64E-04
ETHANE
8,01
0,00
0,00
0,00
1,11E-03
ETHYLENE
1,52
0,00
0,00
0,00
4,80E-04
PROPANE
10,9
0,00
0,00
0,00
1,24E-03
PROPENE
4,23
0,00
0,00
0,00
1,39E-03
IBUTANE
2,52
0,00
0,00
0,00
1,93E-04
BUTANE
11,8
0,00
0,00
0,00
1,29E-03
1-BUTENE
4,49
0,00
0,00
0,00
1,10E-03
IPENTANE
5,52
0,00
0,00
0,00
3,01E-04
PENTANE
8,19
0,00
0,00
0,00
5,81E-04
DEA
0,00
0,00
0,00
25,0
24,6
NBP38*
0,00
0,00
0,00
0,00
0,00
NBP45*
5,10E-03
0,00
0,00
0,00
0,00
NBP55.*
1,47
0,00
0,00
0,00
0,00
NBP65*
1,03
0,00
0,00
0,00
0,00
NBP75*
0,699
0,00
0,00
0,00
0,00
NBP85*
0,418
0,00
0,00
0,00
0,00
NBP95*
0,218
0,00
0,00
0,00
0,00
NBP105*
0,103
0,00
0,00
0,00
0,00
NBP115*
1,49
0,00
0,00
0,00
0,00
NBP125*
1,09
0,00
0,00
0,00
0,00
NBP135*
0,594
0,00
0,00
0,00
0,00
NBP145*
0,256
0,00
0,00
0,00
0,00
NBP155*
7,46E-02
0,00
0,00
0,00
0,00
NBP165*
2,36E-02
0,00
0,00
0,00
0,00
NBP175*
6,64E-03
0,00
0,00
0,00
0,00
NBP185*
7,55E-04
0,00
0,00
0,00
0,00
NBP195*
1,21E-04
0,00
0,00
0,00
0,00
NBP205*
0,00
0,00
0,00
0,00
0,00
NBP215*
0,00
0,00
0,00
0,00
0,00
NBP225*
0,00
0,00
0,00
0,00
0,00
NBP235*
0,00
0,00
0,00
0,00
0,00
NBP245*
0,00
0,00
0,00
0,00
0,00
NBP255*
0,00
0,00
0,00
0,00
0,00
NBP265*
0,00
0,00
0,00
0,00
0,00
NBP275*
0,00
0,00
0,00
0,00
0,00
NBP285*
0,00
0,00
0,00
0,00
0,00
NBP295*
0,00
0,00
0,00
0,00
0,00
NBP305*
0,00
0,00
0,00
0,00
0,00
NBP315*
0,00
0,00
0,00
0,00
0,00
NBP325*
0,00
0,00
0,00
0,00
0,00
NBP335*
0,00
0,00
0,00
0,00
0,00
NBP345*
0,00
0,00
0,00
0,00
0,00
NBP355*
0,00
0,00
0,00
0,00
0,00
NOTES: (1) For details of the dissolved species on this stream refer to pertinent vendor document. (2) This stream may contain up to 60 pmm of H2S. This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 171 of 193
STREAM Nº
90
DESCRIPTION
OFF GAS TO 011-C-0007
BRINE TO WWT
SOUR WATER TO SWS
LEAN AMINE
RICH AMINE
NBP365*
0,00
0,00
0,00
0,00
0,00
NBP375*
0,00
0,00
0,00
0,00
0,00
NBP385*
0,00
0,00
0,00
0,00
0,00
NBP395*
0,00
0,00
0,00
0,00
0,00
NBP405*
0,00
0,00
0,00
0,00
0,00
NBP415*
0,00
0,00
0,00
0,00
0,00
NBP425*
0,00
0,00
0,00
0,00
0,00
NBP435*
0,00
0,00
0,00
0,00
0,00
NBP445*
0,00
0,00
0,00
0,00
0,00
NBP455*
0,00
0,00
0,00
0,00
0,00
NBP470*
0,00
0,00
0,00
0,00
0,00
NBP490*
0,00
0,00
0,00
0,00
0,00
NBP510*
0,00
0,00
0,00
0,00
0,00
NBP530*
0,00
0,00
0,00
0,00
0,00
NBP550*
0,00
0,00
0,00
0,00
0,00
NBP570*
0,00
0,00
0,00
0,00
0,00
NBP590*
0,00
0,00
0,00
0,00
0,00
NBP610*
0,00
0,00
0,00
0,00
0,00
NBP630*
0,00
0,00
0,00
0,00
0,00
NBP660*
0,00
0,00
0,00
0,00
0,00
NBP700*
0,00
0,00
0,00
0,00
0,00
NBP740*
0,00
0,00
0,00
0,00
0,00
NBP780*
0,00
0,00
0,00
0,00
0,00
NBP820*
0,00
0,00
0,00
0,00
0,00
NBP860*
0,00
0,00
0,00
0,00
0,00
NBP900*
0,00
0,00
0,00
0,00
0,00
NBP940*
0,00
0,00
0,00
0,00
0,00
NBP980*
0,00
0,00
0,00
0,00
0,00
Component
Rev.
91 (1)
Rev.
96 (2)
Rev.
97
Rev.
98
Rev.
Mass Frac (%)
NOTES: (1) For details of the dissolved species on this stream refer to pertinent vendor document. (2) This stream may contain up to 60 pmm of H2S. This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
99
DESCRIPTION
REFLUX 011-C-0001
Component
REV: 03 Date: 12-MAY-11 Rev.
100
TR Project No.: 02020 Page 172 of 193
Rev.
REFLUX 011-C-0002
Mass Frac (%)
H2O
0,260
5,82E-02
H2S
0,00
3,41E-02
HYDROGEN
0,00
0,00
AIR
0,00
0,00
METHANE
0,00
1,32E-03 3,84E-02
ETHANE
1,08E-02
ETHYLENE
0,00
0,00
PROPANE
0,350
0,352
PROPENE
0,00
0,00
IBUTANE
0,275
0,382 1,63
BUTANE
1,44
1-BUTENE
0,00
0,00
IPENTANE
1,73
2,17
PENTANE
3,55
4,05
DEA
0,00
0,00
NBP38*
0,524
1,20
NBP45*
1,55
2,10
NBP55.*
2,07
2,70
NBP65*
2,90
3,64
NBP75*
4,11
5,00
NBP85*
5,68
6,71
NBP95*
7,34
8,45
NBP105*
9,22
10,3
NBP115*
11,1
12,0
NBP125*
12,8
12,7
NBP135*
13,8
11,8
NBP145*
12,8
9,15
NBP155*
6,67
4,15
NBP165*
1,63
1,13
NBP175*
0,251
0,217
NBP185*
1,95E-02
2,20E-02
NBP195*
1,99E-03
2,90E-03
NBP205*
1,96E-04
3,73E-04
NBP215*
0,00
0,00
NBP225*
0,00
0,00
NBP235*
0,00
0,00
NBP245*
0,00
0,00
NBP255*
0,00
0,00
NBP265*
0,00
0,00
NBP275*
0,00
0,00
NBP285*
0,00
0,00
NBP295*
0,00
0,00
NBP305*
0,00
0,00
NBP315*
0,00
0,00
NBP325*
0,00
0,00
NBP335*
0,00
0,00
NBP345*
0,00
0,00
NBP355*
0,00
0,00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
99
DESCRIPTION
REFLUX 011-C-0001
REFLUX 011-C-0002
NBP365*
0,00
0,00
NBP375*
0,00
0,00
NBP385*
0,00
0,00
NBP395*
0,00
0,00
NBP405*
0,00
0,00
NBP415*
0,00
0,00
NBP425*
0,00
0,00
NBP435*
0,00
0,00
NBP445*
0,00
0,00
NBP455*
0,00
0,00
NBP470*
0,00
0,00
NBP490*
0,00
0,00
NBP510*
0,00
0,00
NBP530*
0,00
0,00
NBP550*
0,00
0,00
NBP570*
0,00
0,00
NBP590*
0,00
0,00
NBP610*
0,00
0,00
NBP630*
0,00
0,00
NBP660*
0,00
0,00
NBP700*
0,00
0,00
NBP740*
0,00
0,00
NBP780*
0,00
0,00
NBP820*
0,00
0,00
NBP860*
0,00
0,00
NBP900*
0,00
0,00
NBP940*
0,00
0,00
NBP980*
0,00
0,00
Component
Rev.
100
TR Project No.: 02020 Page 173 of 193
Rev.
Mass Frac (%)
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
7.2.
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 174 of 193
PHYSICAL PROPERTIES – KEROSENE IN DIESEL POOL CASE STREAM Nº
1
DESCRIPTION
CRUDE
Rev.
2 WILD NAPHTHA
Rev.
3 TOTAL NAPHTHA
Rev.
4 KEROSENE TO LP HDS
Rev.
5
Rev.
KEROSENE TO STORAGE
----- TOTAL STREAM ----KG-MOL/HR
4743,9
90,5
1772,0
783,4
87,3
KG/HR
1179247,0
8500,0
153122,2
120112,0
13388,1
TEMPERATURE
°C
38,9
70,0
43,3
64,6
43,1
PRESSURE
BAR(GA)
2,0
5,0
7,0
7,0
7,0
248,6
93,9
86,4
153,3
153,3
RATE
MOLECULAR WEIGHT KCAL/KG
-503,4
-506,4
-533,9
-499,3
-510,5
KCAL/HR
-5,94E+08
-4,30E+06
-8,18E+07
-6,00E+07
-6,84E+06
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
4743,9
90,5
1772,0
783,4
87,3
KG/HR
1179247,0
8500,0
153122,2
120112,0
13388,1
M3/HR
1347,9
13,1
233,7
160,8
17,5
GAL(US)/MIN
5934,4
57,6
1029,1
708,0
77,2
M3/HR
1330,8
12,2
226,9
153,3
17,1
248,6
93,9
86,4
153,3
153,3
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-503,4
-506,4
-533,9
-499,3
-510,5
CP
KCAL/KG-C
0,457
0,582
0,565
0,536
0,513
DENSITY
KG/M3
874,9
649,9
655,1
746,9
763,6
0,033
0,030
0,040
0,059
0,061
Z FACTOR SURFACE TENSION
DYNE/CM
22,9
13,5
14,9
20,8
22,6
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,117
0,088
0,092
0,112
0,116
VISCOSITY
CP
9,3
0,3
0,3
0,7
0,9
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
6
DESCRIPTION
LAGO TO LP HDS
Rev.
7 LAGO TO STORAGE
Rev.
TR Project No.: 02020 Page 175 of 193 8+9 HAGO TO HP HDS/ STORAGE
Rev.
10+11 LVGO TO HP HDS/ STORAGE
Rev.
12
Rev.
HVGO TO DHC/MHC
----- TOTAL STREAM ----KG-MOL/HR
530,9
58,9
415,3
146,8
580,4
KG/HR
108518,0
12034,0
108877,4
40601,3
247700,0
TEMPERATURE
°C
50,1
50,1
50,0
50,0
162,8
PRESSURE
BAR(GA)
7,0
7,0
7,5
7,5
13,3
204,4
204,4
262,2
276,6
426,8
RATE
MOLECULAR WEIGHT KCAL/KG
-506,9
-506,9
-502,6
-499,6
-435,7
KCAL/HR
-5,50E+07
-6,10E+06
-5,47E+07
-2,03E+07
-1,08E+08
MOLE FRACTION LIQUID
0,991
0,991
0,991
1,000
1,000
MOLE FRACTION FREE WATER
0,009
0,009
0,009
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
530,9
58,9
415,3
146,8
580,4
KG/HR
108518,0
12034,0
108877,4
40601,3
247700,0
M3/HR
134,3
14,9
127,7
47,1
296,9
GAL(US)/MIN
591,4
65,6
562,1
207,6
1307,2
M3/HR
130,5
14,5
124,4
46,0
264,3
204,4
204,4
262,2
276,6
426,8
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-506,9
-506,9
-502,6
-499,6
-435,7
CP
KCAL/KG-C
0,494
0,494
0,467
0,462
0,565
DENSITY
KG/M3
807,9
807,9
852,8
861,1
834,3
-
-
-
0,102
0,202
Z FACTOR SURFACE TENSION
DYNE/CM
-
-
-
27,5
22,1
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,125
0,125
0,133
0,134
0,126
VISCOSITY
CP
2,2
2,2
5,7
6,6
3,5
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
13
DESCRIPTION
HVGO TO STORAGE
Rev.
14 VAC.RESIDUE TO STORAGE
Rev.
TR Project No.: 02020 Page 176 of 193 15 VAC. RESIDUE TO DCU
Rev.
16 PREFLASH OVERHEAD
Rev.
17
Rev.
NAPHTHA FROM PREFLASH
----- TOTAL STREAM ----KG-MOL/HR
64,5
40,6
365,9
2236,1
1602,9
KG/HR
27504,4
34865,0
314284,6
142333,2
89126,9
TEMPERATURE
°C
90,0
180,0
210,0
138,3
110,2
PRESSURE
BAR(GA)
7,0
7,0
10,2
3,7
3,0
426,8
858,9
858,9
63,7
55,6
RATE
MOLECULAR WEIGHT KCAL/KG
-474,3
-424,1
-407,3
-661,4
-754,4
KCAL/HR
-1,30E+07
-1,48E+07
-1,28E+08
-9,41E+07
-6,72E+07
MOLE FRACTION LIQUID
1,000
1,000
1,000
0,000
0,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
2236,1
1602,9
KG/HR
-
-
-
142333,2
89126,9
M3/HR
-
-
-
15094,9
11986,4
M3/HR
-
-
-
52870,5
37898,9
-
-
-
63,7
55,6
-
-661,4
-754,4 0,514
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
CP
KCAL/KG-C
-
-
-
0,535
DENSITY
KG/M3
-
-
-
9,43
7,44
-
-
-
0,928
0,939
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
0,021
0,020
VISCOSITY
CP
-
-
-
0,01
0,01
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
64,5
40,6
365,9
-
-
KG/HR
27504,4
34865,0
314284,6
-
-
M3/HR
31,2
36,4
335,2
-
-
GAL(US)/MIN
137,2
160,3
1475,6
-
-
M3/HR
MOLECULAR WEIGHT
29,3
33,1
298,5
-
-
426,8
858,9
858,9
-
-
ENTHALPY
KCAL/KG
-474,3
-424,1
-407,3
-
-
CP
KCAL/KG-C
0,489
0,545
0,574
-
-
DENSITY
KG/M3
882,9
957,6
937,7
-
-
0,128
0,191
0,256
-
-
Z FACTOR SURFACE TENSION
DYNE/CM
26,5
24,8
23,4
-
-
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,137
0,144
0,140
-
-
VISCOSITY
CP
12,6
36,9
19,7
-
-
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
18
DESCRIPTION
TOPPED CRUDE
Rev.
19 CDU OVERHEAD
Rev.
TR Project No.: 02020 Page 177 of 193 20 ATM. RESIDUE
Rev.
21 VDU OVERHEAD
Rev.
22
Rev.
RECOVERED OIL
----- TOTAL STREAM ----KG-MOL/HR
3804,0
3167,3
1207,8
1515,2
52,8
KG/HR
1102062,9
198385,7
671785,6
34397,1
7689,7
TEMPERATURE
°C
186,9
116,9
350,8
82,4
50,3
PRESSURE
BAR(GA)
3,9
1,0
14,9
-0,9
7,5
289,7
62,6
556,2
22,7
145,7
RATE
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-426,8
-763,7
-317,3
-2496,1
-507,6
KCAL/HR
-4,70E+08
-1,51E+08
-2,13E+08
-8,59E+07
-3,90E+06
MOLE FRACTION LIQUID
1,000
-
1,000
0,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1)
KG-MOL/HR
-
3167,3
-
1515,2
-
KG/HR
-
198385,7
-
34397,1
-
M3/HR
-
48976,9
-
394631,3
-
M3/HR
-
74889,8
-
35826,4
-
-
62,6
-
22,7
-
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-763,7
-
-2496,1
-
CP
KCAL/KG-C
-
0,501
-
0,445
-
DENSITY
KG/M3
-
4,05
-
0,09
-
-
0,960
-
0,998
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
0,018
-
0,019
-
VISCOSITY
CP
-
0,01
-
0,01
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
3804,0
-
1207,8
-
52,8
KG/HR
1102062,9
-
671785,6
-
7689,7
M3/HR
1407,4
-
878,7
-
10,2
GAL(US)/MIN
6196,5
-
3868,7
-
45,0
M3/HR
1210,7
-
676,1
-
9,9
289,7
-
556,2
-
145,7
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-426,8
-
-317,3
-
-507,6
CP
KCAL/KG-C
0,599
-
0,701
-
0,524
DENSITY
KG/M3
783,1
-
764,5
-
751,7
0,047
-
0,223
-
0,061
Z FACTOR SURFACE TENSION
DYNE/CM
15,4
-
13,0
-
21,3
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,102
-
0,105
-
0,112
VISCOSITY
CP
1,3
-
0,9
-
0,8
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
23
DESCRIPTION
OFF GAS
Rev.
24 WASHED OFF GAS
Rev.
TR Project No.: 02020 Page 178 of 193 25 HAGO+LVGO TO HP HDS
Rev.
26 HAGO+LVGO TO STORAGE
Rev.
27
Rev.
FRESH CRUDE TO 011-E-0002
----- TOTAL STREAM ----KG-MOL/HR
22,8
16,8
580,6
34,3
4743,9
KG/HR
871,3
599,0
148400,0
8766,1
1179247,0
TEMPERATURE
°C
50,0
65,0
50,0
50,0
51,7
PRESSURE
BAR(GA)
0,3
1,8
7,5
7,0
26,2
38,2
35,7
255,6
255,6
248,6
RATE
MOLECULAR WEIGHT KCAL/KG
-527,8
-568,8
-502,1
-502,1
-496,9
KCAL/HR
-4,60E+05
-3,41E+05
-7,45E+07
-4,40E+06
-5,86E+08
MOLE FRACTION LIQUID
0,000
0,000
0,994
0,994
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,006
0,006
0,000
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1)
KG-MOL/HR
22,8
16,8
-
-
-
KG/HR
871,3
599,0
-
-
-
M3/HR
466,7
164,6
-
-
-
M3/HR
539,3
396,7
-
-
-
38,2
35,7
-
-
-
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-527,8
-568,8
-
-
-
CP
KCAL/KG-C
0,404
0,449
-
-
-
DENSITY
KG/M3
1,87
3,64
-
-
-
0,990
0,982
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,021
0,025
-
-
-
VISCOSITY
CP
0,01
0,01
-
-
-
KG-MOL/HR
-
-
580,6
34,3
4743,9
KG/HR
-
-
148400,0
8766,1
1179247,0
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
M3/HR
-
-
174,6
10,3
1359,5
GAL(US)/MIN
-
-
768,7
45,4
5985,5
M3/HR
-
-
170,2
10,1
1330,8
-
-
255,6
255,6
248,6
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-502,1
-502,1
-496,9
CP
KCAL/KG-C
-
-
0,469
0,469
0,471
DENSITY
KG/M3
-
-
849,9
849,9
867,4
-
-
-
-
0,289
Z FACTOR SURFACE TENSION
DYNE/CM
-
-
-
-
21,8
THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
0,131
0,131
0,115
VISCOSITY
CP
-
-
5,4
5,4
7,4
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
28
DESCRIPTION
FRESH CRUDE TO
FRESH CRUDE TO
011-E-0003 A/D
011-E-0004 A/B
Rev.
29
Rev.
TR Project No.: 02020 Page 179 of 193 30 FRESH CRUDE TO 011-E-0005
Rev.
31 FRESH CRUDE TO 011-E-0006
Rev.
32
Rev.
FRESH CRUDE TO 011-E-0007 A/D
----- TOTAL STREAM ----KG-MOL/HR
4743,9
4743,9
4743,9
4743,9
4743,9
KG/HR
1179247,0
1179247,0
1179247,0
1179247,0
1179247,0
TEMPERATURE
°C
57,9
81,0
92,4
99,1
106,0
PRESSURE
BAR(GA)
25,5
22,3
20,5
19,6
18,8
248,6
248,6
248,6
248,6
248,6
RATE
MOLECULAR WEIGHT KCAL/KG
-494,0
-482,7
-477,0
-473,5
-469,8
KCAL/HR
-5,83E+08
-5,69E+08
-5,62E+08
-5,58E+08
-5,54E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
4743,9
4743,9
4743,9
4743,9
4743,9
KG/HR
1179247,0
1179247,0
1179247,0
1179247,0
1179247,0
M3/HR
1367,0
1396,8
1412,2
1421,5
1431,2
GAL(US)/MIN
6018,9
6150,0
6217,6
6258,7
6301,5
M3/HR
1330,8
1330,8
1330,8
1330,8
1330,8
248,6
248,6
248,6
248,6
248,6
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-494,0
-482,7
-477,0
-473,5
-469,8
CP
KCAL/KG-C
0,478
0,504
0,517
0,524
0,531
DENSITY
KG/M3
862,6
844,2
835,1
829,6
823,9
0,278
0,233
0,211
0,200
0,190
Z FACTOR SURFACE TENSION
DYNE/CM
21,3
19,5
18,6
18,1
17,6
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,113
0,108
0,106
0,104
0,103
VISCOSITY
CP
6,7
4,5
3,5
3,1
2,7
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
33
DESCRIPTION
FRESH CRUDE TO 011-E-0008
Rev.
34 FRESH CRUDE TO 011-E-0009
Rev.
TR Project No.: 02020 Page 180 of 193 35 FRESH CRUDE TO DESALTER 011-X-0002
Rev.
36 DESALTED CRUDE TO 011-G-0002 A/B
Rev.
37
Rev.
DESALTED CRUDE TO 011-E-0011A/B 011-E-0012A/B
----- TOTAL STREAM ----KG-MOL/HR
4743,9
4743,9
4743,9
5293,4
5293,4
KG/HR
1179247,0
1179247,0
1179247,0
1189145,4
1189145,4
TEMPERATURE
°C
132,4
141,9
150,5
145,0
157,0
PRESSURE
BAR(GA)
16,2
15,6
15,1
12,0
32,6
248,6
248,6
248,6
224,6
224,6
RATE
MOLECULAR WEIGHT KCAL/KG
-455,5
-450,2
-445,3
-475,2
-468,0
KCAL/HR
-5,37E+08
-5,31E+08
-5,25E+08
-5,65E+08
-5,57E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
0,930
0,942
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,070
0,058
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
4743,9
4743,9
4743,9
5293,4
5293,4
KG/HR
1179247,0
1179247,0
1179247,0
1189145,4
1189145,4
M3/HR
1470,4
1485,2
1499,0
1498,5
1510,6
GAL(US)/MIN
6473,9
6539,3
6600,0
6597,6
6650,9
M3/HR
1330,8
1330,8
1330,8
1340,7
1340,7
248,6
248,6
248,6
224,6
224,6
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-455,5
-450,2
-445,3
-475,2
-468,0
CP
KCAL/KG-C
0,556
0,565
0,573
0,572
0,582
DENSITY
KG/M3
802,0
794,0
786,7
793,6
787,2
0,158
0,151
0,145
-
-
Z FACTOR SURFACE TENSION
DYNE/CM
15,6
15,0
14,4
-
-
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,096
0,093
0,090
0,102
0,098
VISCOSITY
CP
1,8
1,6
1,4
1,5
1,3
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
38
DESCRIPTION
DESALTED CRUDE TO 011-E-0013
Rev.
39 DESALTED CRUDE TO 011-E-0014 A/F
Rev.
TR Project No.: 02020 Page 181 of 193 40 DESALTED CRUDE TO 011-FV-0006
Rev.
41 DESALTED CRUDE TO 011-C-0001
Rev.
42
Rev.
PREFLASH OVERHEAD TO 011-D-0003
----- TOTAL STREAM ----KG-MOL/HR
5293,4
5293,4
5293,4
5293,4
2236,1
KG/HR
1189145,4
1189145,4
1189145,4
1189145,4
142333,2
TEMPERATURE
°C
169,4
180,9
200,0
188,9
110,2
PRESSURE
BAR(GA)
31,3
30,4
28,4
3,9
3,0
224,6
224,6
224,6
224,6
63,7
RATE
MOLECULAR WEIGHT KCAL/KG
-460,8
-453,9
-442,3
-442,3
-710,2
KCAL/HR
-5,48E+08
-5,40E+08
-5,26E+08
-5,26E+08
-1,01E+08
MOLE FRACTION LIQUID
0,957
1,000
1,000
0,734
0,224
MOLE FRACTION FREE WATER
0,043
0,000
0,000
0,000
0,063
KG-MOL/HR
-
-
-
1406,0
1593,0
KG/HR
-
-
-
84673,7
88610,6
M3/HR
-
-
-
10466,9
11871,1
M3/HR
-
-
-
33243,5
37665,3
-
-
-
60,2
55,6
-
-678,9
-753,3 0,514
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
CP
KCAL/KG-C
-
-
-
0,565
DENSITY
KG/M3
-
-
-
8,09
7,46
-
-
-
0,952
0,938
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
0,026
0,020
VISCOSITY
CP
-
-
-
0,01
0,01
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
5293,4
5293,4
5293,4
3887,4
643,1
KG/HR
1189145,4
1189145,4
1189145,4
1104471,6
53722,6
M3/HR
1530,2
1546,9
1583,2
1421,7
84,0
GAL(US)/MIN
6737,2
6810,9
6970,5
6259,6
370,0
M3/HR
1340,7
1340,7
1340,7
1217,9
74,2
224,6
224,6
224,6
284,1
83,5
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-460,8
-453,9
-442,3
-424,1
-639,2
CP
KCAL/KG-C
0,593
0,602
0,618
0,601
0,633
DENSITY
KG/M3
777,1
768,7
751,1
776,9
639,2
-
0,243
0,224
0,047
-
Z FACTOR SURFACE TENSION
DYNE/CM
-
15,5
14,0
14,4
-
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,098
0,105
0,094
0,094
0,091
VISCOSITY
CP
1,1
1,0
0,8
1,2
0,2
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
43
DESCRIPTION
MPS TO 011-C-0001
Rev.
44
Rev.
TR Project No.: 02020 Page 182 of 193 45 (2)
Rev.
46 (2)
Rev.
47
TOPPED CRUDE TO
TOPPED CRUDE TO
TOPPED CRUDE TO
TOPPED CRUDE TO
011-E-0016 A/B
011-E-0017 A/B
011-E-0018 A/B
011-E-0019 A/F
Rev.
----- TOTAL STREAM ----KG-MOL/HR
249,8
3804,0
3804,0
3804,0
3804,0
KG/HR
4500,0
1102062,9
1102062,9
1102062,9
1102062,9
TEMPERATURE
°C
250,0
201,5
222,1
230,0
244,8
PRESSURE
BAR(GA)
14,5
33,5
32,5
32,0
30,6
18,0
289,7
289,7
289,7
289,7
RATE
MOLECULAR WEIGHT KCAL/KG
-3103,7
-417,5
-404,8
-399,8
-390,4
KCAL/HR
-1,40E+07
-4,60E+08
-4,46E+08
-4,41E+08
-4,30E+08
MOLE FRACTION LIQUID
0,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
ENTHALPY
----- TOTAL VAPOR -----RATE
KG-MOL/HR
249,8
-
-
-
-
KG/HR
4500,0
-
-
-
-
M3/HR
662,7
-
-
-
-
M3/HR
5906,2
-
-
-
-
18,0
-
-
-
-
ENTHALPY
KCAL/KG
-3103,7
-
-
-
-
CP
KCAL/KG-C
0,580
-
-
-
-
DENSITY
KG/M3
6,79
-
-
-
-
0,945
-
-
-
-
STD. VAPOR RATE (1) MOLECULAR WEIGHT
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,035
-
-
-
-
VISCOSITY
CP
0,02
-
-
-
-
KG-MOL/HR
-
3804,0
3804,0
3804,0
3804,0
KG/HR
-
1102062,9
1102062,9
1102062,9
1102062,9
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
M3/HR
-
1420,1
1451,5
1464,2
1489,3
GAL(US)/MIN
-
6252,3
6390,6
6446,8
6557,3
M3/HR
-
1210,7
1210,7
1210,7
1210,7
-
289,7
289,7
289,7
289,7
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-417,5
-404,8
-399,8
-390,4
CP
KCAL/KG-C
-
0,610
0,626
0,633
0,645
DENSITY
KG/M3
-
776,1
759,3
752,7
740,0
-
0,326
0,310
0,304
0,287
Z FACTOR SURFACE TENSION
DYNE/CM
-
14,4
13,0
12,5
11,5
THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
0,097
0,090
0,088
0,083
VISCOSITY
CP
-
1,1
0,9
0,8
0,7
NOTES: (1) Standard conditions: 15°C and 1 atm. (2) Total flowrate through heat exchangers has been considered on the Heat and Material Balance for this stream.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
48
DESCRIPTION
TOPPED CRUDE TO 011-E-0020 A/F
Rev.
49 TOPPED CRUDE TO 011-F-0001
Rev.
TR Project No.: 02020 Page 183 of 193 50 TOPPED CRUDE TO 011-C-0002
Rev.
51 HAGO PA TO 011-G-0012 A/B
Rev.
52
Rev.
HAGO PA TO 011-C-0002
----- TOTAL STREAM ----KG-MOL/HR
3804,0
3804,0
3804,0
3593,8
2649,5
KG/HR
1102062,9
1102062,9
1102062,9
901480,6
664602,1
TEMPERATURE
°C
275,5
296,8
366,0
306,8
260,7
PRESSURE
BAR(GA)
28,6
26,4
2,0
1,4
1,4
289,7
289,7
289,7
250,8
250,8
RATE
MOLECULAR WEIGHT KCAL/KG
-370,3
-355,9
-293,0
-348,5
-380,1
KCAL/HR
-4,08E+08
-3,92E+08
-3,23E+08
-3,14E+08
-2,53E+08
MOLE FRACTION LIQUID
1,000
1,000
0,418
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
2212,9
-
-
KG/HR
-
-
358222,7
-
-
M3/HR
-
-
36914,2
-
-
M3/HR
-
-
52322,3
-
-
-
-
161,9
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-268,7
-
-
CP
KCAL/KG-C
-
-
0,685
-
-
DENSITY
KG/M3
-
-
9,70
-
-
-
-
0,946
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
0,031
-
-
VISCOSITY
CP
-
-
0,01
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
3804,0
3804,0
1591,1
3593,8
2649,5
KG/HR
1102062,9
1102062,9
743840,2
901480,6
664602,1
M3/HR
1546,2
1591,4
1035,9
1394,1
967,5
GAL(US)/MIN
6807,8
7006,5
4560,9
6138,0
4259,7
M3/HR
1210,7
1210,7
764,9
1039,2
766,2
289,7
289,7
467,5
250,8
250,8
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-370,3
-355,9
-304,7
-348,5
-380,1
CP
KCAL/KG-C
0,668
0,684
0,717
0,703
0,668
DENSITY
KG/M3
712,7
692,5
718,1
646,6
686,9
0,264
0,242
0,037
0,020
0,020
Z FACTOR SURFACE TENSION
DYNE/CM
9,7
8,5
10,0
9,3
12,2
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,071
0,063
0,078
0,081
0,092
VISCOSITY
CP
0,5
0,4
0,6
0,2
0,3
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
53
DESCRIPTION
HAGO TO 011-C-0006
Rev.
54 HAGO TO 011-G-0013 A/B
Rev.
TR Project No.: 02020 Page 184 of 193 55 HAGO TO 011-E-0009 A/B
Rev.
56 HAGO TO 011-E-0002
Rev.
57
Rev.
HAGO TO 011-A-0004
----- TOTAL STREAM ----KG-MOL/HR
532,0
415,3
415,3
415,3
415,3
KG/HR
133450,1
108877,4
108877,4
108877,4
108877,4
TEMPERATURE
°C
306,8
292,7
238,9
153,2
96,0
PRESSURE
BAR(GA)
1,4
1,5
13,2
12,2
11,5
250,8
262,2
262,2
262,2
262,2
RATE
MOLECULAR WEIGHT KCAL/KG
-348,5
-360,1
-396,0
-448,4
-479,9
KCAL/HR
-4,65E+07
-3,92E+07
-4,31E+07
-4,88E+07
-5,22E+07
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
0,999
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,001
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
532,0
415,3
415,3
415,3
415,3
KG/HR
133450,1
108877,4
108877,4
108877,4
108877,4
M3/HR
206,4
162,3
151,8
139,4
132,5
GAL(US)/MIN
908,6
714,5
668,4
613,7
583,4
M3/HR
153,8
124,4
124,4
124,4
124,4
250,8
262,2
262,2
262,2
262,2
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-348,5
-360,1
-396,0
-448,4
-479,9
CP
KCAL/KG-C
0,703
0,690
0,647
0,576
0,519
DENSITY
KG/M3
646,6
670,9
717,1
781,2
821,7
0,020
0,020
0,122
0,125
-
Z FACTOR SURFACE TENSION
DYNE/CM
9,3
11,0
14,5
20,3
-
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,081
0,091
0,102
0,118
0,127
VISCOSITY
CP
0,2
0,2
0,4
0,9
2,3
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
58
DESCRIPTION
HAGO TO 011-E-0035
Rev.
59 LAGO PA TO 011-G-0010 A/B
Rev.
TR Project No.: 02020 Page 185 of 193 60 LAGO PA TO 011-C-0002
Rev.
61 LAGO TO 011-C-0005
Rev.
62
Rev.
LAGO TO 011-G-0011 A/B
----- TOTAL STREAM ----KG-MOL/HR
415,3
4554,5
3543,4
727,5
588,7
KG/HR
108877,4
900764,8
700801,2
143881,2
120337,2
TEMPERATURE
°C
65,0
246,9
202,0
246,9
233,3
PRESSURE
BAR(GA)
10,8
1,3
1,3
1,3
1,3
262,2
197,8
197,8
197,8
204,4
RATE
MOLECULAR WEIGHT KCAL/KG
-495,4
-389,1
-418,6
-389,1
-399,9
KCAL/HR
-5,39E+07
-3,50E+08
-2,93E+08
-5,60E+07
-4,81E+07
MOLE FRACTION LIQUID
0,992
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,008
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
415,3
4554,5
3543,4
727,5
588,7
KG/HR
108877,4
900764,8
700801,2
143881,2
120337,2
M3/HR
129,2
1399,5
1025,4
223,5
181,1
GAL(US)/MIN
568,7
6161,9
4514,5
984,3
797,5
M3/HR
124,4
1091,0
848,8
174,3
144,8
262,2
197,8
197,8
197,8
204,4
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-495,4
-389,1
-418,6
-389,1
-399,9
CP
KCAL/KG-C
0,485
0,677
0,641
0,677
0,664
DENSITY
KG/M3
842,9
643,6
683,5
643,6
664,4
-
0,016
0,017
0,016
0,017
Z FACTOR SURFACE TENSION
DYNE/CM
-
10,3
13,5
10,3
12,0
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,131
0,084
0,095
0,084
0,092
VISCOSITY
CP
4,3
0,2
0,3
0,2
0,2
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
63
DESCRIPTION
LAGO TO 011-E-0006
Rev.
64 LAGO TO 011-E-0024
Rev.
TR Project No.: 02020 Page 186 of 193 65 LAGO TO 011-A-0003 A/B
Rev.
66 LAGO TO 011-E-0034
Rev.
67
Rev.
KERO PA TO 011-G-0008 A/B
----- TOTAL STREAM ----KG-MOL/HR
588,7
588,7
588,7
588,7
4886,8
KG/HR
120337,2
120337,2
120337,2
120337,2
713337,6
TEMPERATURE
°C
173,8
113,4
85,5
64,8
172,3
PRESSURE
BAR(GA)
13,3
12,6
12,1
11,4
1,1
204,4
204,4
204,4
204,4
146,0
RATE
MOLECULAR WEIGHT KCAL/KG
-437,8
-473,3
-488,6
-499,4
-438,8
KCAL/HR
-5,27E+07
-5,70E+07
-5,88E+07
-6,01E+07
-3,13E+08
MOLE FRACTION LIQUID
1,000
1,000
0,996
0,992
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,004
0,008
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
588,7
588,7
588,7
588,7
4886,8
KG/HR
120337,2
120337,2
120337,2
120337,2
713337,6
M3/HR
168,1
157,8
153,7
150,9
1102,7
GAL(US)/MIN
739,9
694,9
676,8
664,2
4855,0
M3/HR
144,8
144,8
144,8
144,8
918,2
204,4
204,4
204,4
204,4
146,0
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-437,8
-473,3
-488,6
-499,4
-438,8
CP
KCAL/KG-C
0,614
0,561
0,533
0,511
0,637
DENSITY
KG/M3
716,1
762,4
782,9
797,7
646,9
0,110
0,114
-
-
0,013
Z FACTOR SURFACE TENSION
DYNE/CM
16,3
20,8
-
-
11,8
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,104
0,116
0,120
0,123
0,089
VISCOSITY
CP
0,4
0,8
1,2
1,6
0,2
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
REV: 03 Date: 12-MAY-11 68 KERO PA TO 011-C-0002
DESCRIPTION
Rev.
69 KERO TO 011-C-0005
Rev.
TR Project No.: 02020 Page 187 of 193 70 KERO TO 011-G-0009 A/B
Rev.
71 KERO TO 011-E-0001
----- TOTAL STREAM -----
Rev.
72
KG-MOL/HR
3977,5
1137,6
870,7
870,7
3367,7
KG/HR
580600,3
166061,6
133500,1
133500,1
210937,4
TEMPERATURE
°C
125,1
172,3
218,2
145,7
94,7
PRESSURE
BAR(GA)
1,1
1,1
1,2
11,0
0,6
146,0
146,0
153,3
153,3
62,6
RATE
MOLECULAR WEIGHT KCAL/KG
-468,0
-438,8
-406,3
-452,7
-810,7
KCAL/HR
-2,72E+08
-7,29E+07
-5,42E+07
-6,04E+07
-1,71E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
0,195
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,072
KG-MOL/HR
-
-
-
-
2470,5
KG/HR
-
-
-
-
134326,9
M3/HR
-
-
-
-
45285,5
M3/HR
-
-
-
-
58414,4
-
-
-
-
54,4
ENTHALPY
Rev.
CDU OVERHEAD TO 011-A-0001 A/H
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-890,2
CP
KCAL/KG-C
-
-
-
-
0,484
DENSITY
KG/M3
-
-
-
-
2,97
-
-
-
-
0,967
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
0,017
VISCOSITY
CP
-
-
-
-
0,01
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
3977,5
1137,6
870,7
870,7
897,2
KG/HR
580600,3
166061,6
133500,1
133500,1
76610,5
M3/HR
842,0
256,7
218,5
196,1
114,2
GAL(US)/MIN
3707,1
1130,2
962,0
863,2
502,7
M3/HR
747,4
213,8
170,4
170,4
103,7
146,0
146,0
153,3
153,3
85,4
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-468,0
-438,8
-406,3
-452,7
-671,2
CP
KCAL/KG-C
0,596
0,637
0,674
0,610
0,617
DENSITY
KG/M3
689,6
646,9
611,0
680,9
671,0
0,014
0,013
0,014
0,078
-
Z FACTOR SURFACE TENSION
DYNE/CM
15,5
11,8
8,8
14,3
-
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,099
0,089
0,079
0,096
0,100
VISCOSITY
CP
0,3
0,2
0,2
0,3
0,3
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 188 of 193
STREAM Nº
73
74
75
76
DESCRIPTION
CDU OVERHEAD TO 011-D-0004
PREFLASH NAPHTHA FROM 011-E-0021
NAPHTHA TO 011-E-0021
NAPHTHA TO 011-D-0005
Rev.
77 (2)
Rev.
ATM. RESIDUE TO 011-C-0003
----- TOTAL STREAM ----KG-MOL/HR
3367,7
1602,9
2349,5
2349,5
1736,4
KG/HR
210937,4
89126,9
163526,9
163526,9
681752,5
TEMPERATURE
°C
63,2
65,0
70,8
43,0
407,0
PRESSURE
BAR(GA)
0,3
2,5
2,5
1,8
-0,6
62,6
55,6
69,6
69,6
392,6
RATE
MOLECULAR WEIGHT KCAL/KG
-929,0
-894,4
-719,0
-739,5
-297,2
KCAL/HR
-1,96E+08
-7,97E+07
-1,18E+08
-1,21E+08
-2,03E+08
MOLE FRACTION LIQUID
0,545
0,496
0,710
0,754
0,391
MOLE FRACTION FREE WATER
0,451
0,348
0,239
0,246
0,000
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1)
KG-MOL/HR
13,0
251,4
119,5
-
1056,7
KG/HR
749,7
14053,2
6518,6
-
208100,0
M3/HR
269,9
1899,2
923,4
-
145342,4
M3/HR
307,4
5944,0
2826,6
-
24986,0
57,7
55,9
54,5
-
196,9
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-616,0
-561,2
-578,1
-
-344,1
CP
KCAL/KG-C
0,448
0,466
0,470
-
0,684
DENSITY
KG/M3
2,78
7,40
7,06
-
1,43
0,975
0,941
0,946
-
0,989
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,016
0,017
0,018
-
0,030
VISCOSITY
CP
0,01
0,01
0,01
-
0,01
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
3354,7
1351,5
2230,0
2349,5
679,7
KG/HR
210187,7
75073,7
157008,2
163526,9
473652,5
M3/HR
302,2
115,3
243,0
244,4
623,5
GAL(US)/MIN
1330,7
507,6
1069,7
1076,0
2745,2
M3/HR
286,0
108,1
226,2
237,4
463,5
62,7
55,5
70,4
69,6
696,9
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-930,1
-956,8
-724,9
-739,5
-276,6
CP
KCAL/KG-C
0,630
0,648
0,617
0,594
0,733
DENSITY
KG/M3
695,4
651,1
646,3
669,1
759,7
-
-
-
-
0,007
Z FACTOR SURFACE TENSION
DYNE/CM
-
-
-
-
12,4
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,110
0,098
0,092
0,098
0,102
VISCOSITY
CP
0,4
0,3
0,3
0,3
0,9
NOTES: (1) Standard conditions: 15°C and 1 atm. (2) Cracking in the vacuum heater has been considered.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001 STREAM Nº
REV: 03 Date: 12-MAY-11 78
79
80
81
VAC. RESIDUE
VAC. RESIDUE TO 011-E-0018 A/D
VAC. RESIDUE TO 011-E-0014 A/F
HVGO TO 011-G-0017 A/B
TO 011-G-0018 A/B
DESCRIPTION
TR Project No.: 02020 Page 189 of 193 Rev.
82
Rev.
HVGO TO 011-E-0016 A/B
----- TOTAL STREAM ----KG-MOL/HR
531,5
531,5
406,5
2167,8
1605,3
KG/HR
456548,1
456548,1
349149,6
1016215,5
752515,5
TEMPERATURE
°C
361,1
308,0
275,5
323,6
281,0
PRESSURE
BAR(GA)
-0,8
16,5
15,5
-0,9
19,4
858,9
858,9
858,9
468,8
468,8
RATE
MOLECULAR WEIGHT KCAL/KG
-311,1
-346,8
-367,7
-333,4
-362,2
KCAL/HR
-1,42E+08
-1,58E+08
-1,28E+08
-3,39E+08
-2,73E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
531,5
531,5
406,5
2167,8
1605,3
KG/HR
456548,1
456548,1
349149,6
1016215,5
752515,5
M3/HR
546,3
523,6
390,6
1395,7
988,6
GAL(US)/MIN
2405,4
2305,1
1719,6
6145,2
4352,7
M3/HR
433,6
433,6
331,6
1073,4
794,8
858,9
858,9
858,9
468,8
468,8
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-311,1
-346,8
-367,7
-333,4
-362,2
CP
KCAL/KG-C
0,696
0,656
0,631
0,697
0,664
DENSITY
KG/M3
835,7
872,0
894,0
728,1
761,2
0,003
0,357
0,348
0,002
0,273
Z FACTOR SURFACE TENSION
DYNE/CM
16,4
18,8
20,3
13,9
16,2
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,120
0,127
0,132
0,104
0,111
VISCOSITY
CP
2,7
5,4
7,6
0,6
0,9
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 190 of 193
STREAM Nº
83
84
85
86
DESCRIPTION
HVGO FROM 011-E-0016 A/B
MVGO TO 011-G-0016 A/B
MVGO + HVGO TO 011-E-0015 A/B
MVGO + HVGO TO 011-E-0010 A/B
Rev.
87
Rev.
LVGO TO 011-G-0015 A/B
----- TOTAL STREAM ----KG-MOL/HR
365,8
279,0
644,9
644,9
1906,0
KG/HR
171502,8
103701,5
275204,4
275204,4
527214,4
TEMPERATURE
°C
253,6
271,2
260,5
209,5
147,1
PRESSURE
BAR(GA)
18,7
-0,9
17,0
15,6
-0,9
468,8
371,7
426,8
426,8
276,6
RATE
MOLECULAR WEIGHT KCAL/KG
-380,2
-370,4
-376,2
-408,2
-449,6
KCAL/HR
-6,52E+07
-3,84E+07
-1,04E+08
-1,12E+08
-2,37E+08
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
365,8
279,0
644,9
644,9
1906,0
KG/HR
171502,8
103701,5
275204,4
275204,4
527214,4
M3/HR
219,7
139,2
359,0
343,0
665,2
GAL(US)/MIN
967,4
612,9
1580,6
1510,3
2928,8
M3/HR
181,1
112,5
293,6
293,6
596,9
468,8
371,7
426,8
426,8
276,6
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-380,2
-370,4
-376,2
-408,2
-449,6
CP
KCAL/KG-C
0,643
0,659
0,649
0,608
0,566
DENSITY
KG/M3
780,6
745,0
766,6
802,3
792,6
0,270
0,002
0,226
0,220
0,001
Z FACTOR SURFACE TENSION
DYNE/CM
17,7
15,0
16,6
19,4
20,7
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,115
0,106
0,111
0,119
0,118
VISCOSITY
CP
1,2
0,6
0,9
1,7
1,2
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 191 of 193
STREAM Nº
88
89
90
91
DESCRIPTION
LVGO TO 011-A-0005 A/H
LVGO TO 011-A-0005 A/H
OFF GAS TO 011-C-0007
BRINE TO WWT
Rev.
92
Rev.
HAGO PA TO NHDT UNIT
----- TOTAL STREAM ----KG-MOL/HR
1568,3
1568,3
19,9
5270,5
2384,4
KG/HR
433814,4
433814,4
721,4
95100,0
598100,0
TEMPERATURE
°C
126,5
60,0
41,5
41,5
308,6
PRESSURE
BAR(GA)
10,8
9,0
2,1
9,0
12,6
276,6
276,6
36,2
18,0
250,8
RATE
MOLECULAR WEIGHT KCAL/KG
-460,8
-494,9
-438,5
-3767,4
-347,1
KCAL/HR
-2,00E+08
-2,15E+08
-3,16E+05
-3,58E+08
-2,08E+08
MOLE FRACTION LIQUID
1,000
1,000
0,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
1,000
0,000
KG-MOL/HR
-
-
19,9
-
-
KG/HR
-
-
721,4
-
-
M3/HR
-
-
164,4
-
-
M3/HR
-
-
471,3
-
-
-
-
36,2
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-438,5
-
-
CP
KCAL/KG-C
-
-
0,398
-
-
DENSITY
KG/M3
-
-
4,39
-
-
-
-
0,978
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
0,021
-
-
VISCOSITY
CP
-
-
0,01
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
1568,3
1568,3
-
5270,5
2384,4
KG/HR
433814,4
433814,4
-
95100,0
598100,0
M3/HR
536,6
507,7
-
95,8
922,7
GAL(US)/MIN
2362,6
2235,4
-
421,7
4062,7
M3/HR
491,1
491,1
-
95,2
689,5
276,6
276,6
-
18,0
250,8
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-460,8
-494,9
-
-3767,4
-347,1
CP
KCAL/KG-C
0,546
0,474
-
0,994
0,703
DENSITY
KG/M3
808,4
854,4
-
993,0
648,2
0,122
0,117
-
0,007
0,109
Z FACTOR SURFACE TENSION
DYNE/CM
22,1
26,8
-
69,6
9,2
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,121
0,132
-
0,540
0,081
VISCOSITY
CP
1,6
5,6
-
0,7
0,2
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
TR Project No.: 02020 Page 192 of 193
STREAM Nº
93
94 (2)
95 (2)
96
DESCRIPTION
HAGO PA FROM NHDT UNIT
LAGO PA TO NHDT UNIT
LAGO PA FROM NHDT UNIT
SOUR WATER TO SWS
Rev.
97
Rev.
LEAN AMINE
----- TOTAL STREAM ----KG-MOL/HR
2384,4
1946,7
1946,7
4252,3
351,9
KG/HR
598100,0
385000,0
385000,0
76604,8
8000,0
TEMPERATURE
°C
287,0
229,0
179,0
55,5
65,0
PRESSURE
BAR(GA)
10,1
10,6
8,1
7,1
2,0
250,8
197,8
197,8
18,0
22,7
RATE
MOLECULAR WEIGHT KCAL/KG
-362,2
-401,0
-433,1
-3748,9
-3076,9
KCAL/HR
-2,17E+08
-1,54E+08
-1,67E+08
-2,87E+08
-2,46E+07
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
1,000
0,000
KG-MOL/HR
-
-
-
-
-
KG/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
-
VISCOSITY
CP
-
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
2384,4
1946,7
1946,7
4252,3
351,9
KG/HR
598100,0
385000,0
385000,0
76604,8
8000,0
M3/HR
897,3
581,6
547,0
77,8
7,9
GAL(US)/MIN
3950,7
2560,5
2408,3
342,3
34,9
M3/HR
689,5
466,3
466,3
76,8
7,8
250,8
197,8
197,8
18,0
22,7 -3076,9
MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-362,2
-401,0
-433,1
-3748,9
CP
KCAL/KG-C
0,687
0,662
0,621
1,007
0,903
DENSITY
KG/M3
666,6
662,0
703,9
985,2
1009,8 0,002
0,090
0,083
0,068
0,005
SURFACE TENSION
DYNE/CM
10,6
11,6
15,1
66,8
62,2
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,086
0,089
0,100
0,558
0,437
VISCOSITY
CP
0,2
0,2
0,4
0,5
0,8
Z FACTOR
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-290001
REV: 03 Date: 12-MAY-11
STREAM Nº
98
DESCRIPTION
RICH AMINE
Rev.
99 REFLUX 011-C-0001
Rev.
TR Project No.: 02020 Page 193 of 193 100 REFLUX 011-C-0002
Rev.
101
Rev.
HVGO TO 011-C-0003
----- TOTAL STREAM ----KG-MOL/HR
355,1
496,9
978,7
125,0
KG/HR
8122,5
50750,8
97523,0
107398,5
TEMPERATURE
°C
68,2
110,2
63,2
274,8
PRESSURE
BAR(GA)
2,0
3,7
1,0
-0,8
22,9
102,1
99,6
858,9
RATE
MOLECULAR WEIGHT KCAL/KG
-3027,3
-486,7
-509,0
-368,4
KCAL/HR
-2,46E+07
-2,47E+07
-4,96E+07
-3,96E+07
MOLE FRACTION LIQUID
1,000
1,000
1,000
1,000
MOLE FRACTION FREE WATER
0,000
0,000
0,000
0,000
KG-MOL/HR
-
-
-
-
KG/HR
-
-
-
-
M3/HR
-
-
-
-
M3/HR
-
-
-
-
-
-
-
-
ENTHALPY
----- TOTAL VAPOR -----RATE
STD. VAPOR RATE (1) MOLECULAR WEIGHT ENTHALPY
KCAL/KG
-
-
-
-
CP
KCAL/KG-C
-
-
-
-
DENSITY
KG/M3
-
-
-
-
-
-
-
-
Z FACTOR THERMAL CONDUCTIVITY
KCAL/HR-M-C
-
-
-
-
VISCOSITY
CP
-
-
-
-
----- TOTAL LIQUID ----RATE
STD. LIQUID RATE (1)
KG-MOL/HR
355,1
496,9
978,7
125,0
KG/HR
8122,5
50750,8
97523,0
107398,5
M3/HR
8,0
80,6
146,3
120,1
GAL(US)/MIN
35,1
355,1
644,3
528,7
M3/HR
MOLECULAR WEIGHT
8,0
71,1
138,0
102,0
22,9
102,1
99,6
858,9 -368,4
ENTHALPY
KCAL/KG
-3027,3
-486,7
-509,0
CP
KCAL/KG-C
0,886
0,614
0,573
0,632
DENSITY
KG/M3
1018,7
629,3
666,4
894,3 0,004
0,002
0,024
0,011
SURFACE TENSION
DYNE/CM
63,2
12,2
15,5
20,3
THERMAL CONDUCTIVITY
KCAL/HR-M-C
0,423
0,087
0,094
0,132
VISCOSITY
CP
0,8
0,2
0,3
7,6
Z FACTOR
NOTES: (1) Standard conditions: 15°C and 1 atm.
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-290001
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 6.
LIGHT ARABIAN CASE PFDS AND H&M BALANCE Document Number
Description PFD FOR CDU AND VDU LIGHT ARABIAN CASE – CRUDE PREHEAT/PREFLASH 1/2 PFD FOR CDU AND VDU LIGHT ARABIAN CASE – CRUDE PREHEAT/PREFLASH 2/2 PFD FOR CDU AND VDU LIGHT ARABIAN CASE – CRUDE DISTILLATION PFD FOR CDU AND VDU LIGHT ARABIAN CASE – VACUUM DISTILLATION 1 / 2 PFD FOR CDU AND VDU LIGHT ARABIAN CASE – VACUUM DISTILLATION 2 / 2 PFD FOR CDU AND VDU LIGHT ARABIAN CASE – PROCESS STREAM SUMMARY 1 PFD FOR CDU AND VDU LIGHT ARABIAN CASE – PROCESS STREAM SUMMARY 2 LIGHT ARABIAN CASE – HEAT AND MATERIAL BALANCE
Rev. NA NA NA NA NA NA NA NA
Prolect no- Unit
Wmentd e
2271 -011
CN
JUBAIL EXPORT REFINERY PROJECT ARAMCO OVERSEAS COMPANY AND TOTAL C W P . TYPE
PXBSE
NOL. REIGUT
DFNSIíY
BGln3
. 5
m3
6 RIR 7 cm 8
H E T m
9 ETHiNE 10 ETHYLENE 11 PROPAllE 12 PROPENE 13 I B U T W í 14 B U í W 15 BUTEN6-1 16 lPENfANE 17 PBNTANE 10 NBF 38 19 VBP 45 20 NBP 55 21 RBP 65 22 RBP 15 23 liap 85 24 NBP 95 25 105 26 NBP 115 27 NBO 123 28 P 135 29 NBP 145 30 1(8P 155 3 1 NBP 165 32 ABP 175 33 llBP 1 8 5 34 m 195 35 liBP 205 36 NBP 215 37 NBP 225 38 NBP 235 39 NBP 245 4 0 NBP 255 41 NBP 265 42 NBP 275 43 NBP 2 8 5 44 m P Z95 45 NBO 305 4 6 NBP 315 47 NBP 325 48 NBP 535 49 NIIP 345 50 NBP 355 51 NBP 365 52 NBP S75 53 NBP 385 54 UBP 3= 65 °C)
3.-
DELETED
4.-
DENSITY AT NORMAL OPERATING CONDITIONS (ONLY FOR LIQUID AND TWO PHASE LINES).
5.-
TESTING IDENTIFICATION: H = HYDRAULIC PNEU = PNEUMATIC
6.-
STEAM OUT DESIGN CONDITIONS: 0.5 BARA (HALF VACUUM) @ 120 °C.
7.-
TWO PHASE FLOW: POSSIBLE UNSTABLE FLOW. ANCHOR SECURELY.
8.-
TO IDENTIFY PENDING DATA REFER TO CORRESPONDING PIPING AND INSTRUMENT DIAGRAM.
9.-
TO IDENTIFY SERVICE CODE SEE SA-JER-DSAAA-TRJR-480003.
10.-
FOR ADDITIONAL PSV DATA, SEE DOCUMENT Nº 2271-110-CN-1545-01_A
11.-
TWO CONDITIONS ARE SHOWN FOR PRESSURE AND TEMPERATURE: LEFT VALUE FOR DESIGN CONDITION AND RIGHT VALUE FOR DESIGN ALTERNATIVE CONDITION (FULL VACUUM, HALF VACUUM )
SA-JER-DS011-TRJR-380001
Page 3 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM 011-D-0013
SA-JER-DS011-TRJR-480105
2"
ACS
011
040001
101CS1P
SA-JER-DS011-TRJR-480105
2"
ACS
011
040001
101CS1P 2"-RWA-011040301-301CG0W-N
SA-JER-DS011-TRJR-480105
4"
ACS
011
040001
101CS1P
SA-JER-DS011-TRJR-480105
2"
ACS
011
040001
SA-JER-DS011-TRJR-480105
2"
ACS
011
SA-JER-DS011-TRJR-480105
2"
ACS
011
TO
TYPE
TEMP. (ºC)
INSULATION (NOTE 2)
TYPE
FLUID
THICKNESS (mm)
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
Reducer
-
-
P
25
WATER
Liquid
1000
0.00
107.00
-
-
0.00
135.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
-
2"-ACS-011040001-101CS1P-P
-
-
P
25
WATER
Liquid
1000
0.00
107
-
-
0.00
135.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
-
Reducer
Reducer
-
-
P
25
WATER
Liquid
1000
0.00
107
-
-
0.00
135.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
-
101CS1P
4"-ACS-011040001-101CS1P-P
011-TI-0178
-
-
P
25
WATER
Liquid
1000
0.00
107
-
-
0.00
135.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
-
040001
101CS1P
Reducer
2"-OLW-011040306-101CS1P-N
-
-
P
25
WATER
Liquid
1000
0.00
107
-
-
0.00
135.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
040001
101CS1P
2"-ACS-011040001-101CS1P-P
2"-ACS-011040001-101CS1P-P
-
-
P
25
WATER
Liquid
1000
0.00
107
-
-
0.00
135.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480094
2"
AMD
011
036302
101CH2S
2"-AMI-011036009-101CH4S-P
SA-JER-DS011-TRJR-480233
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
036302
SA-JER-DS011-TRJR-480095
2"
AMD
011
036303
101CH2S
SA-JER-DS011-TRJR-480094
2"-AMD-011036304-101CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
101CH2S
2"-AMI-011036016-103CH2S-P
SA-JER-DS011-TRJR-480233
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
036303
SA-JER-DS011-TRJR-480095
2"
AMD
011
036304
101CH2S
SA-JER-DS011-TRJR-480095
2"-AMD-011079302-101CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
101CH2S
2"-AMI-011036017-103CH2S-P
SA-JER-DS011-TRJR-480233
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
036304
SA-JER-DS011-TRJR-480095
2"
AMD
011
036305
101CH2S
SA-JER-DS011-TRJR-480095
2"-AMD-011036303-101CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
101CH2S
2"-AMI-011036018-103CH2S-P
SA-JER-DS011-TRJR-480233
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
036305
SA-JER-DS011-TRJR-480094
2"
AMD
011
036306
101CH2S
SA-JER-DS011-TRJR-480095
2"-AMD-011079302-101CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
101CH2S
2"-AMI-011036007-103CS2D-P
SA-JER-DS011-TRJR-480233
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
D
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
SA-JER-DS011-TRJR-480233
2"
AMD
011
036306
101CH2S
SA-JER-DS011-TRJR-480094
2"-AMD-011036302-101CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
D
YES
M
Y
N
N
Y
N
N
-
079001
101CH2S
011-D-0025
2"-AMD-011079005-103CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
1"
AMD
SA-JER-DS011-TRJR-480233
2"
AMD
011
079002
103CH2S
011-G-0027
Reducer
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.70
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
011
079002
103CH2S
Reducer
011-S-0005
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.70
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079002
103CH2S
2"-AMD-011079002-103CH2S-P
011-PDT-0422
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.70
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
AMD
011
079002
103CH2S
2"-AMD-011079002-103CH2S-P
011-PI-0417
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.70
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079002
103CH2S
2"-AMD-011079002-103CH2S-P
Blind flange
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.70
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079002
103CH2S
2"-AMD-011079002-103CH2S-P
011-PI-0440
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.70
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
079003
103CH2S
011-S-0005
SA-JER-DS011-TRJR-480095
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079003
103CH2S
2"-AMD-011079003-103CH2S-P
Blind flange
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079003
103CH2S
011-PI-0441
2"-AMD-011079003-103CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079003
103CH2S
2"-AMD-011079003-103CH2S-P
011-PT-0419
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079003
103CH2S
011-PDT-0422
2"-AMD-011079003-103CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480095
2"
AMD
011
079003
103CH2S
SA-JER-DS011-TRJR-480233
3"-AMI-011036004-103CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1034
7.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
079004
103CH2S
2"-AMD-011079002-103CH2S-P
2"-AMD-011079003-103CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.70
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
079005
103CH2S
2"-AMD-011079001-101CH2S-P
011-G-0027
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079005
103CH2S
2"-AMD-011079005-103CH2S-P
UC
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079005
103CH2S
2"-AMD-011079005-103CH2S-P
011-PI-0316
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
079006
103CH2S
2"-AMD-011079003-103CH2S-P
TRUCK CONNECTIONS
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079006
103CH2S
2"-AMD-011079006-103CH2S-P
Blind flange
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
079007
101CH2S
2"-AMD-011079001-101CH2S-P
Reducer
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079007
101CH2S
Reducer
3/4"-OLW-011079303-101CS1PN
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
079007
101CH2S
2"-AMD-011079007-101CH2S-P
2"-AMD-011079314-101CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079007
101CH2S
011-LG-0134
2"-AMD-011079007-101CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079008
101CH2S
011-LG-0134
3/4"-LFL-011079302-101CH2F-N
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079008
101CH2S
3/4"-AMD-011079008-101CH2SP
Blind flange
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3"
AMD
011
079301
101CH2S
HEADER
011-D-0025
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079301
101CH2S
3"-AMD-011079301-101CH2S-P
Blind flange
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079301
101CH2S
3"-AMD-011079301-101CH2S-P
Blind flange
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079301
101CH2S
3"-AMD-011079301-101CH2S-P
Blind flange
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
079302
101CH2S
2"-AMD-011079306-103CH2S-P
SA-JER-DS011-TRJR-480233
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
079302
101CH2S
SA-JER-DS011-TRJR-480233
3"-AMD-011079301-101CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
079303
101CH2S
2"-AMD-011079309-103CH2S-P
SA-JER-DS011-TRJR-480233
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
079303
101CH2S
SA-JER-DS011-TRJR-480233
2"-AMD-011036305-101CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
1-1/2"
AMD
011
079306
103CH2S
2"-AMD-011079002-103CH2S-P
Reducer
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.70
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079306
103CH2S
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.70
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-380001
1-1/2"-AMD-011079306-103CH2S- 3/4"-OLW-011079302-101CS1PP N
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 4 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480233
2"
AMD
011
079306
103CH2S
Reducer
2"-AMD-011079302-101CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.70
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
1/2"
AMD
011
079306
103CH2S
011-PI-0417
1-1/2"-AMD-011079306-103CH2SP
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.70
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
1-1/2"
AMD
011
079306
103CH2S
2"-AMD-011079005-103CH2S-P
1-1/2"-AMD-011079306-103CH2SP
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.70
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
-
P
25
1045
7.70
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
1-1/2"
AMD
011
079306
1-1/2"-AMD-011079306-103CH2S- 1-1/2"-AMD-011079306-103CH2S103CH2S P P
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079306
103CH2S
011-G-0027
Reducer
-
AMINE CLOSED DRAIN
Liquid
SA-JER-DS011-TRJR-480233
1"
AMD
011
079306
103CH2S
Reducer
1-1/2"-AMD-011079306-103CH2SP
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.70
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
079308
103CH2S
UC
011-S-0005
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.70
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079308
103CH2S
2"-AMD-011079308-103CH2S-P
Blind flange
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.70
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
079309
103CH2S
011-S-0005
2"-AMD-011079303-101CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079309
103CH2S
2"-AMD-011079309-103CH2S-P
3/4"-OLW-011079304-101CS1PN
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. ALTERNATE DESIGN CONDITIONS FV @ 290 ºC. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. ALTERNATE DESIGN CONDITIONS FV @ 290 ºC. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. ALTERNATE DESIGN CONDITIONS: 7 barg. FV@290ºC. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. ALTERNATE DESIGN CONDITIONS: 7 barg. FV@290ºC. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
SA-JER-DS011-TRJR-480233
1"
AMD
011
079311
103CH2S
2"-AMD-011079002-103CH2S-P
1"-AMD-011079313-101CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.70
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079312
103CH2S
1"-AMD-011079311-103CH2S-P
011-SC-0048
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.70
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480275
3/4"
AMD
011
079312
103CH2S
1"-AMD-011079311-103CH2S-P
SAMPLE COOLER
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
7.70
71.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
1"
AMD
011
079313
101CH2S
1"-AMD-011079311-103CH2S-P
Reducer
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
079313
101CH2S
Reducer
011-D-0025
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
079314
101CH2S
2"-AMD-011079007-101CH2S-P
TRUCK CONNECTIONS
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079314
101CH2S
2"-AMD-011079314-101CH2S-P
Blind flange
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
079315
101CH2S
2"-DWA-011079301-101SR0P-N
011-D-0025
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
079316
101CH2S
UC
011-D-0025
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
D
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
3/4"
AMD
011
079316
101CH2S
2"-AMD-011079316-101CH2S-P
Blind flange
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
D
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
079318
101CH2S
011-D-0025
2"-OLW-011079301-101CS1P-N
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
N
Y
N
Y
N
N
-
N
Y
N
Y
N
N
-
STEAM OUT CONDITIONS: 0.5 bara @ 150ºC. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
N
Y
N
Y
N
N
-
STEAM OUT CONDITIONS: 0.5 bara @ 150ºC. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
if insulated M or Q SA-JER-DS011-TRJR-480233
-
AMD
011
079602
103CH2S
011-D-0025
TRIM
-
-
P
-
-
-
-
0.30
71.00
-
-
3.50
100.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480233
-
AMD
011
079603
103CH2S
011-S-0005
TRIM
-
-
P
-
-
-
-
7.70
71.00
-
-
13.10
100.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480137
2"
AMD
011
099301
101CH2S
2"-AMI-011099002-103CS2D-P
SA-JER-DS011-TRJR-480233
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
D
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
099301
101CH2S
SA-JER-DS011-TRJR-480137
2"-AMD-011099302-101CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
D
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480137
2"
AMD
011
099302
101CH2S
2"-AMI-011099003-103CH2S-P
SA-JER-DS011-TRJR-480233
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
150.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
SA-JER-DS011-TRJR-480233
2"
AMD
011
099302
101CH2S
SA-JER-DS011-TRJR-480137
3"-AMD-011079301-101CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
150.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480275
3/4"
AMD
011
200001
103CH2S
SAMPLE COOLER
Reducer
-
-
N
-
AMINE CLOSED DRAIN
Liquid
1045
7.70
60.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
A or Q
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480275
4"
AMD
011
200001
103CH2S
Reducer
Reducer
-
-
N
-
AMINE CLOSED DRAIN
Liquid
1045
7.70
60.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
A or Q
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480275
3/4"
AMD
011
200001
103CH2S
Reducer
Reducer
-
-
N
-
AMINE CLOSED DRAIN
Liquid
1045
7.70
60.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
A or Q
N
Y
N
Y
N
N
-
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
SA-JER-DS011-TRJR-480275
2"
AMD
011
200001
103CH2S
Reducer
2"-AMD-011200303-101CH2S-P
-
-
N
-
AMINE CLOSED DRAIN
Liquid
1045
7.70
60.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
A or Q
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480275
3/4"
AMD
011
200001
103CH2S
3/4"-AMD-011200001-103CH2SN
Reducer
-
-
N
-
AMINE CLOSED DRAIN
Liquid
1045
7.70
60.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
A or Q
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480275
1/2"
AMD
011
200001
103CH2S
Reducer
Reducer
-
-
N
-
AMINE CLOSED DRAIN
Liquid
1045
7.70
60.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
A or Q
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480275
1/4"
AMD
011
200001
103CH2S
Reducer
SAMPLE CYLINDER
-
-
N
-
AMINE CLOSED DRAIN
Liquid
1045
7.70
60.00
-
-
13.10
100.00
-
-
-
NFS
YES
A or Q
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480275
1/4"
AMD
011
200001
103CH2S
SAMPLE CYLINDER
Reducer
-
-
N
-
AMINE CLOSED DRAIN
Liquid
1045
7.70
60.00
-
-
13.10
100.00
-
-
-
NFS
YES
A or Q
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480275
1/2"
AMD
011
200001
103CH2S
Reducer
3/4"-AMD-011200001-103CH2S-N
-
-
N
-
AMINE CLOSED DRAIN
Liquid
1045
7.70
60.00
-
-
13.10
100.00
-
H
19.65
NFS
YES
A or Q
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480275
2"
AMD
011
200301
101CH2S
2"-AMI-011036021-103CH2S-P
SA-JER-DS011-TRJR-480233
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
200301
101CH2S
SA-JER-DS011-TRJR-480275
3"-AMD-011079301-101CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480275
2"
AMD
011
200302
101CH2S
2"-AMI-011200001-103CS2D-N
SA-JER-DS011-TRJR-480233
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
D
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
200302
101CH2S
SA-JER-DS011-TRJR-480275
3"-AMD-011079301-101CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
D
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480275
2"
AMD
011
200303
101CH2S
2"-AMD-011200001-103CH2S-N
SA-JER-DS011-TRJR-480233
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480233
2"
AMD
011
200303
101CH2S
SA-JER-DS011-TRJR-480275
2"-AMD-011200302-101CH2S-P
-
-
P
25
AMINE CLOSED DRAIN
Liquid
1045
0.30
71.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480094
2"
AMI
011
036001
101CH2S
011-C-0007
011-C-0007
-
-
H
25
RICH AMINE
Liquid
1010
1.80
65.00
-
-
5.80
100.00
-
H
8.70
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
2"
AMI
011
036001
101CH2S
2"-AMI-011036002-103CS2D-P
2"-AMI-011036001-101CH2S-H
-
-
H
25
RICH AMINE
Liquid
1010
1.80
65.00
-
-
5.80
100.00
-
H
8.70
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
3/4"
AMI
011
036001
101CH2S
2"-AMI-011036001-101CH2S-H
1"-AMI-011036009-101CH4S-P
-
-
H
25
RICH AMINE
Liquid
1010
1.80
65.00
-
-
5.80
100.00
-
H
8.70
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
2"
AMI
011
036002
103CS2D
3"-AML-011099001-103CS2D-H
2"-AMI-011036001-101CH2S-H
-
-
P
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
3/4"
AMI
011
036002
103CS2D
2"-AMI-011036002-103CS2D-P
Plug
-
-
P
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 5 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480094
3"
AMI
011
036003
103CH2S
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
4"
AMI
011
036003
103CH2S
Reducer
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
2"
AMI
011
036003
103CH2S
4"-AMI-011036003-103CH2S-P
011-TT-0214
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3"
AMI
011
036003
103CH2S
SA-JER-DS011-TRJR-480094
3"-AMI-011036011-103CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3"
AMI
011
036003
103CH2S
3"-AMI-011036003-103CH2S-P
3"-AMI-011036014-103CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
3"
AMI
011
036003
103CH2S
Reducer
SA-JER-DS011-TRJR-480095
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
1"
AMI
011
036004
103CH2S
011-G-0023-A
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
3/4"
AMI
011
036004
103CH2S
3"-AMI-011036004-103CH2S-P
011-PI-0178
-
-
P
25
RICH AMINE
Liquid
1045
6.30
71.00
-
-
13.00
150.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3"
AMI
011
036004
103CH2S
Reducer
3"-AMI-011036004-103CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3/4"
AMI
011
036004
103CH2S
3"-AMI-011036004-103CH2S-P
011-PI-0120
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3"
AMI
011
036004
103CH2S
3"-AMI-011036004-103CH2S-P
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
1-1/2"
AMI
011
036004
103CH2S
Reducer
1-1/2"-AMI-011036004-103CH2SP
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3"
AMI
011
036004
103CH2S
3"-AMI-011036004-103CH2S-P
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
3"
AMI
011
036004
103CH2S
SA-JER-DS011-TRJR-480095
3"-AMI-011036004-103CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
6.30
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
3"
AMI
011
036004
103CH2S
3"-AMI-011036004-103CH2S-P
Gate valve
-
-
P
25
RICH AMINE
Liquid
1045
6.30
71.00
-
-
13.00
150.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
3/4"
AMI
011
036004
103CH2S
3"-AMI-011036004-103CH2S-P
Blind flange
-
-
P
25
RICH AMINE
Liquid
1045
6.30
71.00
-
-
13.00
150.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
1-1/2"
AMI
011
036004
103CH2S
Reducer
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3"
AMI
011
036004
103CH2S
Reducer
3"-AMI-011036004-103CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3"
AMI
011
036004
103CH2S
3"-AMI-011036004-103CH2S-P
SA-JER-DS011-TRJR-480137
-
-
P
25
RICH AMINE
Liquid
1045
6.30
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3"
AMI
011
036004
103CH2S
Reducer
3"-AMI-011036004-103CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
6.30
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
1/2"
AMI
011
036004
103CH2S
011-FT-0154
011-FE-0154
-
-
P
25
RICH AMINE
Liquid
1045
6.30
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
1/2"
AMI
011
036004
103CH2S
011-FT-0154
011-FE-0154
-
-
P
25
RICH AMINE
Liquid
1045
6.30
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
1-1/2"
AMI
011
036004
103CH2S
1-1/2"-AMI-011036004-103CH2SP
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
6.30
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
3"
AMI
011
036005
101CH4S
011-C-0007
011-ZV-0112
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
4.80
100.00
-
H
7.20
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
3"
AMI
011
036006
101CH4S
3"-AML-011099001-103CS2D-H
011-C-0007
-
-
H
25
LEAN AMINE
Liquid
1010
3.50
65.00
-
-
5.80
100.00
-
H
8.70
D
YES
M or Q
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
1-1/2"
AMI
011
036006
101CH4S
1-1/2"-AML-011099001-103CS2DH
Reducer
-
-
H
25
LEAN AMINE
Liquid
1010
3.50
65.00
-
-
5.80
100.00
-
H
8.70
D
YES
M or Q
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
3"
AMI
011
036006
101CH4S
Reducer
3"-AMI-011036006-101CH4S-H
-
-
H
25
LEAN AMINE
Liquid
1010
3.50
65.00
-
-
5.80
100.00
-
H
8.70
D
YES
M or Q
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
3/4"
AMI
011
036007
103CS2D
3"-AML-011099001-103CS2D-H
Insul Brk
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
3/4"
AMI
011
036007
103CS2D
3/4"-AMI-011036007-103CS2D-H
Blind flange
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
3/4"
AMI
011
036007
103CS2D
Insul Brk
Reducer
-
-
P
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M
N
Y
N
N
N
N
-
-
SA-JER-DS011-TRJR-480094
3/4"
AMI
011
036007
103CS2D
3/4"-AMI-011036007-103CS2D-P
Plug
-
-
P
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M
N
Y
N
N
N
N
-
-
SA-JER-DS011-TRJR-480094
2"
AMI
011
036007
103CS2D
Reducer
2"-AMD-011036306-101CH2S-P
-
-
P
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M
N
Y
N
N
N
N
-
-
SA-JER-DS011-TRJR-480094
3/4"
AMI
011
036007
103CS2D
3"-AML-011099001-103CS2D-H
Insul Brk
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M
N
Y
N
N
N
N
-
-
SA-JER-DS011-TRJR-480094
3/4"
AMI
011
036007
103CS2D
3/4"-AMI-011036007-103CS2D-H
UC
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M
N
Y
N
N
N
N
-
-
SA-JER-DS011-TRJR-480094
3/4"
AMI
011
036007
103CS2D
Insul Brk
3/4"-AMI-011036007-103CS2D-P
-
-
P
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M
N
Y
N
N
N
N
-
-
SA-JER-DS011-TRJR-480094
2"
AMI
011
036009
101CH4S
3"-AMI-011036005-101CH4S-P
2"-AMD-011036302-101CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
4.80
100.00
-
H
7.20
NFS
YES
M
N
Y
N
Y
N
N
-
-
SA-JER-DS011-TRJR-480094
3/4"
AMI
011
036009
101CH4S
2"-AMI-011036009-101CH4S-P
3/4"-OLW-011036308-101CS1PN
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
4.80
100.00
-
-
-
NFS
YES
M
N
Y
N
Y
N
N
-
-
SA-JER-DS011-TRJR-480094
3/4"
AMI
011
036009
101CH4S
011-LG-0073
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
4.80
100.00
-
-
-
NFS
YES
M
N
Y
N
Y
N
N
-
-
SA-JER-DS011-TRJR-480094
1"
AMI
011
036009
101CH4S
Reducer
2"-AMI-011036009-101CH4S-P
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
4.80
100.00
-
H
7.20
NFS
YES
M
N
Y
N
Y
N
N
-
-
SA-JER-DS011-TRJR-480094
1"
AMI
011
036009
101CH4S
3/4"-AMI-011036001-101CH2S-H
2"-AMI-011036009-101CH4S-P
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
4.80
100.00
-
H
7.20
NFS
YES
M
N
Y
N
Y
N
N
-
-
SA-JER-DS011-TRJR-480095
3"
AMI
011
036011
103CH2S
3"-AMI-011036003-103CH2S-P
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3/4"
AMI
011
036011
-
-
P
011-ZV-0112
103CH2S
3"-AMI-011036011-103CH2S-P
011-PDT-0133
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3"
AMI
011
036011
103CH2S
3"-AMI-011036011-103CH2S-P
Blind flange
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3/4"
AMI
011
036011
103CH2S
3"-AMI-011036011-103CH2S-P
011-PDT-0133
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3/4"
AMI
011
036011
103CH2S
3"-AMI-011036011-103CH2S-P
UC
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
1-1/2"
AMI
011
036011
103CH2S
Reducer
011-G-0023-A
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
3/4"
AMI
011
036012
103CS2D
3"-AML-011099001-103CS2D-H
011-SC-0044
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480275
3/4"
AMI
011
036012
103CS2D
3"-AMN-011099001-103CS2D-H
SAMPLE COOLER
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3"
AMI
011
036014
103CH2S
3"-AMI-011036003-103CH2S-P
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3"
AMI
011
036014
103CH2S
3"-AMI-011036014-103CH2S-P
Blind flange
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3/4"
AMI
011
036014
103CH2S
3"-AMI-011036014-103CH2S-P
UC
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3/4"
AMI
011
036014
103CH2S
3"-AMI-011036014-103CH2S-P
011-PDT-0134
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3/4"
AMI
011
036014
103CH2S
3"-AMI-011036014-103CH2S-P
011-PDT-0134
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
1-1/2"
AMI
011
036014
103CH2S
Reducer
011-G-0023-B
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
1"
AMI
011
036015
103CH2S
011-G-0023-B
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3"
AMI
011
036015
103CH2S
Reducer
3"-AMI-011036015-103CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3/4"
AMI
011
036015
103CH2S
3"-AMI-011036015-103CH2S-P
011-PI-0121
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3"
AMI
011
036015
103CH2S
3"-AMI-011036015-103CH2S-P
3"-AMI-011036004-103CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
1-1/2"
AMI
011
036016
103CH2S
3"-AMI-011036004-103CH2S-P
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3/4"
AMI
011
036016
103CH2S
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
2"
AMI
011
036016
103CH2S
1-1/2"-AMI-011036016-103CH2S- 3/4"-OLW-011036303-101CS1PP N Reducer
2"-AMD-011036303-101CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
1-1/2"
AMI
011
036016
103CH2S
3"-AMI-011036011-103CH2S-P
1-1/2"-AMI-011036016-103CH2SP
SA-JER-DS011-TRJR-480095
1/2"
AMI
011
036016
103CH2S
011-G-0023-A
1/2"-AMI-011036016-103CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
By Vendor
By Vendor
N
Y
N
Y
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480095
1/2"
AMI
011
036016
103CH2S
1/2"-AMI-011036016-103CH2S-P
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
1"
AMI
011
036016
103CH2S
SA-JER-DS011-TRJR-480095
3/4"
AMI
011
036016
103CH2S
SA-JER-DS011-TRJR-480095
3/4"
AMI
011
036016
103CH2S
SA-JER-DS011-TRJR-480095
1-1/2"
AMI
011
036017
103CH2S
SA-JER-DS011-TRJR-480095
3/4"
AMI
011
036017
103CH2S
SA-JER-DS011-TRJR-480095
2"
AMI
011
036017
103CH2S
1-1/2"-AMI-011036016-103CH2SReducer P 1-1/2"-AMI-011036016-103CH2S011-G-0023-A P 1-1/2"-AMI-011036016-103CH2S3/4"-AMI-011036004-103CH2S-P P 3"-AMI-011036015-103CH2S-P
Reducer
1-1/2"-AMI-011036017-103CH2S- 3/4"-OLW-011036304-101CS1PP N Reducer
2"-AMD-011036304-101CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
1-1/2"
AMI
011
036017
103CH2S
3"-AMI-011036014-103CH2S-P
1-1/2"-AMI-011036017-103CH2SP
SA-JER-DS011-TRJR-480095
1/2"
AMI
011
036017
103CH2S
011-G-0023-B
1/2"-AMI-011036017-103CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
By Vendor
By Vendor
N
Y
N
Y
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480095
1/2"
AMI
011
036017
103CH2S
1/2"-AMI-011036017-103CH2S-P
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
1-1/2"-AMI-011036017-103CH2SReducer P 1-1/2"-AMI-011036017-103CH2S011-G-0023-B P 1-1/2"-AMI-011036017-103CH2S3/4"-AMI-011036015-103CH2S-P P
SA-JER-DS011-TRJR-480095
1"
AMI
011
036017
103CH2S
SA-JER-DS011-TRJR-480095
3/4"
AMI
011
036017
103CH2S
SA-JER-DS011-TRJR-480095
3/4"
AMI
011
036017
103CH2S
SA-JER-DS011-TRJR-480095
3/4"
AMI
011
036018
103CH2S
3"-AMI-011036004-103CH2S-P
SA-JER-DS011-TRJR-480095
3/4"
AMI
011
036018
103CH2S
3/4"-AMI-011036018-103CH2S-P
Blind flange
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
2"
AMI
011
036018
103CH2S
Reducer
2"-AMD-011036305-101CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3/4"
AMI
011
036018
103CH2S
3"-AMI-011036004-103CH2S-P
3/4"-AMI-011036018-103CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3/4"
AMI
011
036018
103CH2S
3/4"-AMI-011036018-103CH2S-P
UC
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3/4"
AMI
011
036020
103CH2S
3"-AMI-011036004-103CH2S-P
3/4"-AMI-011036021-103CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480275
3/4"
AMI
011
036020
103CH2S
3"-AMN-011036004-103CH2S-P
SAMPLE COOLER
-
-
P
25
RICH AMINE
Liquid
1045
8.70
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480095
3/4"
AMI
011
036021
103CH2S
3/4"-AMI-011036020-103CH2S-P
3"-AMI-011036004-103CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
6.30
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
SA-JER-DS011-TRJR-480275
3/4"
AMI
011
036021
103CH2S
3/4"-AMI-011200002-103CH2S-P
3"-AMN-011036004-103CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
6.30
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480275
3/4"
AMI
011
036021
103CH2S
3/4"-AMI-011036021-103CH2S-P
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
6.30
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/2"
AMI
011
036021
103CH2S
Reducer
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
6.30
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-380001
NOTE 6
Page 6 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480275
3/4"
AMI
011
036021
103CH2S
Reducer
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
6.30
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
AMI
011
036021
103CH2S
3/4"-AMI-011036021-103CH2S-P
Plug
-
-
P
25
RICH AMINE
Liquid
1045
6.30
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
2"
AMI
011
036021
103CH2S
Reducer
2"-AMD-011200301-101CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
6.30
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/4"
AMI
011
036021
103CH2S
SAMPLE CYLINDER
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
6.30
71.00
-
-
13.00
100.00
-
-
-
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/2"
AMI
011
036021
103CH2S
Reducer
1/2"-AMI-011036021-103CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
6.30
71.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480094
3"
AMI
011
036022
101CH4S
011-C-0007
3"-OLW-011036307-101CS1P-N
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
4.80
100.00
-
H
7.20
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
2"
AMI
011
036023
101CH4S
UC
011-C-0007
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
4.80
100.00
-
H
7.20
NFS
YES
M
N
Y
N
Y
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@290ºC.
H
SA-JER-DS011-TRJR-480094
1"
AMI
011
036023
101CH4S
2"-AMI-011036023-101CH4S-P
Blind flange
-
-
P
25
RICH AMINE
Liquid
1045
2.00
71.00
-
-
4.80
100.00
-
7.20
NFS
YES
M
N
Y
N
Y
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@290ºC.
SA-JER-DS011-TRJR-480094
3/4"
AMI
011
036301
101CH4S
011-LG-0073
Reducer
-
-
P
25
RICH AMINE
Gas
-
2.00
71.00
-
-
4.20
100.00
-
-
-
M
YES
M
N
POTENTIAL
N
Y
N
N
-
-
SA-JER-DS011-TRJR-480094
1"
AMI
011
036301
101CH4S
Reducer
1"-LFL-011036306-101CH2F-N
-
-
P
25
RICH AMINE
Gas
-
2.00
71.00
-
-
4.20
100.00
-
H
6.30
M
YES
M
N
POTENTIAL
N
Y
N
N
-
-
SA-JER-DS011-TRJR-480094
1"
AMI
011
036301
101CH4S
1"-AMI-011036301-101CH4S-P
Blind flange
-
-
P
25
RICH AMINE
Gas
-
2.00
71.00
-
-
4.20
100.00
-
H
6.30
M
YES
M
N
POTENTIAL
N
Y
N
N
-
-
N
Y
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
Y
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
Y
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
Y
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
Y
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
Y
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
Y
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
Y
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
Y
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
Y
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
Y
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
if insulated M or Q SA-JER-DS011-TRJR-480094
-
AMI
011
036601
103CH2S
011-C-0007
TRIM
-
-
H
-
-
-
-
2.00
71.00
-
-
4.20
100.00
-
Visual Test
0.00
M
YES
SA-JER-DS011-TRJR-480094
2"
AMI
011
036601
103CH2S
011-C-0007
011-LG-0073
-
-
H
25
-
-
-
2.00
71.00
-
-
4.20
100.00
-
H
6.30
M
YES
SA-JER-DS011-TRJR-480094
2"
AMI
011
036601
103CH2S
011-C-0007
011-LT-0074
-
-
H
25
-
-
-
2.00
71.00
-
-
4.20
100.00
-
H
6.30
M
YES
SA-JER-DS011-TRJR-480094
2"
AMI
011
036601
103CH2S
011-C-0007
011-PT-0115-B
-
-
H
25
-
-
-
2.00
71.00
-
-
4.20
100.00
-
H
6.30
M
YES
SA-JER-DS011-TRJR-480094
2"
AMI
011
036601
103CH2S
011-C-0007
011-PI-0119
-
-
H
25
-
-
-
2.00
71.00
-
-
4.20
100.00
-
H
6.30
M
YES
SA-JER-DS011-TRJR-480094
2"
AMI
011
036601
103CH2S
011-C-0007
011-LT-0075
-
-
H
25
-
-
-
2.00
71.00
-
-
4.20
100.00
-
H
6.30
M
YES
SA-JER-DS011-TRJR-480094
2"
AMI
011
036601
103CH2S
011-C-0007
011-LT-0075
-
-
H
25
-
-
-
2.00
71.00
-
-
4.20
100.00
-
H
6.30
M
YES
SA-JER-DS011-TRJR-480094
2"
AMI
011
036601
103CH2S
011-C-0007
011-LT-0074
-
-
H
25
-
-
-
2.00
71.00
-
-
4.20
100.00
-
H
6.30
M
YES
SA-JER-DS011-TRJR-480094
2"
AMI
011
036601
103CH2S
011-C-0007
011-PT-0115-A
-
-
H
25
-
-
-
2.00
71.00
-
-
4.20
100.00
-
H
6.30
M
YES
SA-JER-DS011-TRJR-480094
2"
AMI
011
036601
103CH2S
011-C-0007
011-PI-0117
-
-
H
25
-
-
-
2.00
71.00
-
-
4.20
100.00
-
H
6.30
M
YES
SA-JER-DS011-TRJR-480094
2"
AMI
011
036601
103CH2S
011-C-0007
011-LG-0073
-
-
H
25
-
-
-
2.00
71.00
-
-
4.20
100.00
-
H
6.30
M
YES
SA-JER-DS011-TRJR-480137
3/4"
AMI
011
099002
103CS2D
3"-AML-011099001-103CS2D-H
Insul Brk
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
3/4"
AMI
011
099002
103CS2D
Insul Brk
Reducer
-
-
P
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
3/4"
AMI
011
099002
103CS2D
3/4"-AMI-011099002-103CS2D-P
Plug
-
-
P
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
2"
AMI
011
099002
103CS2D
Reducer
2"-AMD-011099301-101CH2S-P
-
-
P
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
3/4"
AMI
011
099002
103CS2D
3"-AML-011099001-103CS2D-H
Insul Brk
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
3/4"
AMI
011
099002
103CS2D
Insul Brk
3/4"-AMI-011099002-103CS2D-P
-
-
P
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
3/4"
AMI
011
099003
103CH2S
3"-AMI-011036004-103CH2S-P
Reducer
-
-
P
25
RICH AMINE
Liquid
1010
6.30
71.00
-
-
13.00
150.00
-
H
19.50
NFS
YES
M
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
3/4"
AMI
011
099003
103CH2S
3/4"-AMI-011099003-103CH2S-P
Blind flange
-
-
P
25
RICH AMINE
Liquid
1010
6.30
71.00
-
-
13.00
150.00
-
H
19.50
NFS
YES
M
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
2"
AMI
011
099003
103CH2S
Reducer
2"-AMD-011099302-101CH2S-P
-
-
P
25
RICH AMINE
Liquid
1010
6.30
71.00
-
-
13.00
150.00
-
H
19.50
NFS
YES
M
N
Y
N
N
N
N
-
SA-JER-DS011-TRJR-480137
3/4"
AMI
011
099003
103CH2S
3"-AMI-011036004-103CH2S-P
3/4"-AMI-011099003-103CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
6.30
71.00
-
-
13.00
150.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480275
3/4"
AMI
011
200001
103CS2D
SAMPLE COOLER
Reducer
-
-
N
-
LEAN AMINE
Liquid
1010
10.60
60.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
A or Q
N
Y
N
N
N
N
-
NOTE 6.
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
NOTE 6
SA-JER-DS011-TRJR-480275
4"
AMI
011
200001
103CS2D
Reducer
Reducer
-
-
N
-
LEAN AMINE
Liquid
1010
10.60
60.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
A or Q
N
Y
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
AMI
011
200001
103CS2D
Reducer
Reducer
-
-
N
-
LEAN AMINE
Liquid
1010
10.60
60.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
A or Q
N
Y
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
2"
AMI
011
200001
103CS2D
Reducer
2"-AMD-011200302-101CH2S-P
-
-
N
-
LEAN AMINE
Liquid
1010
10.60
60.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
A or Q
N
Y
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
AMI
011
200001
103CS2D
3/4"-AMI-011200001-103CS2D-N
Reducer
-
-
N
-
LEAN AMINE
Liquid
1010
10.60
60.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
A or Q
N
Y
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/2"
AMI
011
200001
103CS2D
Reducer
Reducer
-
-
N
-
LEAN AMINE
Liquid
1010
10.60
60.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
A or Q
N
Y
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/4"
AMI
011
200001
103CS2D
Reducer
SAMPLE CYLINDER
-
-
N
-
LEAN AMINE
Liquid
1010
10.60
60.00
-
-
24.00
100.00
-
-
-
NFS
YES
A or Q
N
Y
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/4"
AMI
011
200001
103CS2D
SAMPLE CYLINDER
Reducer
-
-
N
-
LEAN AMINE
Liquid
1010
10.60
60.00
-
-
24.00
100.00
-
-
-
NFS
YES
A or Q
N
Y
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/2"
AMI
011
200001
103CS2D
Reducer
3/4"-AMI-011200001-103CS2D-N
-
-
N
-
LEAN AMINE
Liquid
1010
10.60
60.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
A or Q
N
Y
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
AMI
011
200002
103CH2S
SAMPLE COOLER
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
8.70
60.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
4"
AMI
011
200002
103CH2S
Reducer
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
8.70
60.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
AMI
011
200002
103CH2S
Reducer
3/4"-AMI-011036021-103CH2S-P
-
-
P
25
RICH AMINE
Liquid
1045
8.70
60.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
AMI
011
200002
103CH2S
3/4"-AMI-011200002-103CH2S-P
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
8.70
60.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
-
SA-JER-DS011-TRJR-480275
1/2"
AMI
011
200002
103CH2S
Reducer
Reducer
-
-
P
25
RICH AMINE
Liquid
1045
8.70
60.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
N
Y
N
Y
N
N
-
-
SA-JER-DS011-TRJR-480275
1/4"
AMI
011
200002
103CH2S
Reducer
SAMPLE CYLINDER
-
-
P
25
RICH AMINE
Liquid
1045
8.70
60.00
-
-
13.00
100.00
-
-
-
NFS
YES
M
N
Y
N
Y
N
N
-
-
SA-JER-DS011-TRJR-480137
3"
AML
011
099001
103CS2D
IP-1307-L
3"-AML-011099001-103CS2D-H
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
95.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
3/4"
AML
011
099001
103CS2D
3"-AML-011099001-103CS2D-H
011-PI-0177
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
95.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
3"
AML
011
099001
103CS2D
3"-AML-011099001-103CS2D-H
SA-JER-DS011-TRJR-480094
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
3"
AML
011
099001
103CS2D
SA-JER-DS011-TRJR-480137
Reducer
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
2"
AML
011
099001
103CS2D
3"-AML-011099001-103CS2D-H
Blind flange
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
4"
AML
011
099001
103CS2D
Reducer
Reducer
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
2"
AML
011
099001
103CS2D
4"-AML-011099001-103CS2D-H
011-TT-0217
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
3"
AML
011
099001
103CS2D
Reducer
Reducer
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
3"
AML
011
099001
103CS2D
3"-AML-011099001-103CS2D-H
Reducer
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
1/2"
AML
011
099001
103CS2D
011-FE-0067
011-FT-0067-A
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
1/2"
AML
011
099001
103CS2D
011-FE-0067
011-FT-0067-B
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
1/2"
AML
011
099001
103CS2D
011-FE-0067
011-FT-0067-B
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
Reducer
1-1/2"-AMI-011036006-101CH4SH
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
1-1/2"
SA-JER-DS011-TRJR-380001
AML
011
099001
103CS2D
Page 7 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
011-FT-0067-A
-
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480094
1/2"
AML
011
099001
103CS2D
011-FE-0067
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
1-1/2"
AML
011
099001
103CS2D
Reducer
Reducer
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
3"
AML
011
099001
103CS2D
Reducer
3"-AMI-011036006-101CH4S-H
-
-
H
25
LEAN AMINE
Liquid
1010
10.60
65.00
-
-
24.00
100.00
-
H
36.00
NFS
YES
M or Q
N
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480023
2"
AWS
011
012001
101CH2S
PREFLASH REFLUX DRUM
Reducer
-
-
P
25
SOUR WATER
Liquid
970
3.80
110.00
-
-
6.50
140.00
-
H
9.75
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480023
1-1/2"
AWS
011
012001
101CH2S
2"-AWS-011012001-101CH2S-P
Reducer
-
-
P
25
SOUR WATER
Liquid
970
3.80
110.00
-
-
6.50
140.00
-
H
9.75
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480023
3/4"
AWS
011
012001
101CH2S
Reducer
3/4"-AWS-011012001-101CH2S-P
-
-
P
25
SOUR WATER
Liquid
970
3.80
110.00
-
-
6.50
140.00
-
H
9.75
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480023
1"
AWS
011
012001
101CH2S
Reducer
Reducer
-
-
P
25
SOUR WATER
Liquid
970
3.80
110.00
-
-
6.50
140.00
-
H
9.75
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480113
2"
AWS
011
012001
101CH2S
SA-JER-DS011-TRJR-480023
4"-AWS-011021001-101CH2S-N
-
-
P
25
SOUR WATER
Liquid
970
1.30
110.00
-
-
6.00
140.00
-
H
9.00
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480023
2"
AWS
011
012001
101CH2S
Reducer
2"-AWS-011012001-101CH2S-P
-
-
P
25
SOUR WATER
Liquid
970
3.80
110.00
-
-
6.50
140.00
-
H
9.75
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480023
2"
AWS
011
012001
101CH2S
2"-AWS-011012001-101CH2S-P
SA-JER-DS011-TRJR-480113
-
-
P
25
SOUR WATER
Liquid
970
1.30
110.00
-
-
6.00
140.00
-
H
9.00
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
Reducer
-
-
P
25
SOUR WATER
Liquid
970
1.30
110.00
-
-
6.00
140.00
-
H
9.00
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480023
3/4"
AWS
011
012001
101CH2S
3/4"-AWS-011012001-101CH2SP
SA-JER-DS011-TRJR-480023
1/2"
AWS
011
012001
101CH2S
011-FE-0148
011-FT-0148
-
-
P
25
SOUR WATER
Liquid
970
1.30
110.00
-
-
6.00
140.00
-
H
9.00
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480023
1-1/2"
AWS
011
012001
101CH2S
Reducer
2"-AWS-011012001-101CH2S-P
-
-
P
25
SOUR WATER
Liquid
970
1.30
110.00
-
-
6.00
140.00
-
H
9.00
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480023
1/2"
AWS
011
012001
101CH2S
011-FE-0148
011-FT-0148
-
-
P
25
SOUR WATER
Liquid
970
1.30
110.00
-
-
6.00
140.00
-
H
9.00
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480023
3/4"
AWS
011
012002
101CH2S
2"-AWS-011012001-101CH2S-P
011-SC-0027
-
-
P
25
SOUR WATER
Liquid
970
3.80
110.00
-
-
6.50
140.00
-
H
9.75
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480023
3/4"
AWS
011
012003
101CH2S
011-SC-0027
2"-AWS-011012001-101CH2S-P
-
-
P
25
SOUR WATER
Liquid
970
1.30
110.00
-
-
6.00
140.00
-
H
9.00
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480023
3/4"
AWS
011
012004
101CH2S
2"-AWS-011012001-101CH2S-P
Reducer
-
-
P
25
NAPHTHA
Liquid
970
3.80
110.00
-
-
6.50
140.00
-
H
9.75
NFS
YES
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480023
3/4"
AWS
011
012004
101CH2S
3/4"-AWS-011012004-101CH2SP
3/4"-OLW-011012303-101CS1PN
-
-
P
25
NAPHTHA
Liquid
970
3.80
110.00
-
-
6.50
140.00
-
H
9.75
NFS
YES
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480023
2"
AWS
011
012004
101CH2S
Reducer
2"-CLD-011012304-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
970
3.80
110.00
-
-
6.50
140.00
-
H
9.75
NFS
YES
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480023
3/4"
AWS
011
012004
101CH2S
011-LDG-0007
3/4"-AWS-011012004-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
970
3.80
110.00
-
-
6.50
140.00
-
H
9.75
NFS
YES
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480023
3/4"
AWS
011
012004
101CH2S
011-LG-0005
3/4"-AWS-011012004-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
970
3.80
110.00
-
-
6.50
140.00
-
H
9.75
NFS
YES
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480023
2"
AWS
011
012006
101CH2S
011-D-0003
2"-OLW-011012305-101CS1P-N
-
-
P
25
SOUR WATER
Liquid
970
3.00
110.00
-
-
5.50
140.00
-
H
8.25
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480023
2"
AWS
011
012007
103CH2S
2"-AWS-011012001-101CH2S-P
011-AT-0021
-
-
P
25
SOUR WATER
Liquid
970
3.80
110.00
-
-
6.50
140.00
-
H
9.75
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480023
2"
AWS
011
012008
103CH2S
011-AT-0021
2"-AWS-011012001-101CH2S-P
-
-
P
25
SOUR WATER
Liquid
970
1.30
110.00
-
-
6.00
140.00
-
H
9.00
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480023
3/4"
AWS
011
012009
101CH2S
2"-AWS-011012001-101CH2S-P
Reducer
-
-
P
25
SOUR WATER
Liquid
970
3.80
110.00
-
-
6.50
140.00
-
H
9.75
D
YES
M
N
N
N
Y
N
N
-
-
Blind flange
-
-
P
25
SOUR WATER
Liquid
970
3.80
110.00
-
-
6.50
140.00
-
H
9.75
D
YES
M
N
N
N
Y
N
N
-
-
2"-CLD-011012307-101CH2S-P
-
-
P
25
SOUR WATER
Liquid
970
3.80
110.00
-
-
6.50
140.00
-
H
9.75
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
-
-
P
25
SOUR WATER
Liquid
970
3.80
110.00
-
-
6.50
140.00
-
H
9.75
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
SA-JER-DS011-TRJR-480023
3/4"
AWS
011
012009
101CH2S
3/4"-AWS-011012009-101CH2SP
SA-JER-DS011-TRJR-480023
2"
AWS
011
012009
101CH2S
Reducer
SA-JER-DS011-TRJR-480023
3/4"
AWS
011
012009
101CH2S
2"-AWS-011012001-101CH2S-P 3/4"-AWS-011012009-101CH2S-P
if insulated M or Q SA-JER-DS011-TRJR-480023
-
AWS
011
012601
103CH2S
011-D-0003
TRIM
-
-
P
-
-
-
-
3.00
110.00
-
-
5.50
140.00
-
Visual Test
0.00
D
YES
SA-JER-DS011-TRJR-480023
2"
AWS
011
012601
103CH2S
PREFLASH REFLUX DRUM
011-LDT-0008
-
-
P
25
-
-
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
D
YES
SA-JER-DS011-TRJR-480023
2"
AWS
011
012601
103CH2S
PREFLASH REFLUX DRUM
011-LDT-0008
-
-
P
25
-
-
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
D
YES
SA-JER-DS011-TRJR-480023
2"
AWS
011
012601
103CH2S
PREFLASH REFLUX DRUM
011-LDG-0007
-
-
P
25
-
-
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
D
YES
SA-JER-DS011-TRJR-480023
2"
AWS
011
012601
103CH2S
PREFLASH REFLUX DRUM
011-LDT-0009
-
-
P
25
-
-
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
D
YES
SA-JER-DS011-TRJR-480023
2"
AWS
011
012601
103CH2S
PREFLASH REFLUX DRUM
011-LDT-0009
-
-
P
25
-
-
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
D
YES
SA-JER-DS011-TRJR-480023
2"
AWS
011
012601
103CH2S
PREFLASH REFLUX DRUM
011-LDG-0007
-
-
P
25
-
-
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
D
YES
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
SA-JER-DS011-TRJR-480046
6"
AWS
011
019001
101CH2S
011-D-0004
Reducer
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
1/2"
AWS
011
019001
101CH2S
011-FE-0149
011-FT-0149
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
4"
AWS
011
019001
101CH2S
Reducer
6"-AWS-011019001-101CH2S-P
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3"
AWS
011
019001
101CH2S
3"-AWS-011019001-101CH2S-P
Reducer
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
1/2"
AWS
011
019001
101CH2S
011-FE-0149
011-FT-0149
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3"
AWS
011
019001
101CH2S
Reducer
Reducer
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480113
6"
AWS
011
019001
101CH2S
SA-JER-DS011-TRJR-480046
011-D-0006
-
-
P
25
SOUR WATER
Liquid
988
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
6"
AWS
011
019001
101CH2S
Reducer
6"-AWS-011019001-101CH2S-P
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
6"
AWS
011
019001
101CH2S
6"-AWS-011019001-101CH2S-P
SA-JER-DS011-TRJR-480113
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3"
AWS
011
019001
101CH2S
Reducer
3"-AWS-011019001-101CH2S-P
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
4"
AWS
011
019001
101CH2S
6"-AWS-011019001-101CH2S-P
Reducer
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
4"
AWS
011
019004
101CH2S
6"-AWS-011019001-101CH2S-P
4"-AWS-011019004-101CH2S-P
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
4"
AWS
011
019004
101CH2S
4"-AWS-011019004-101CH2S-P
4"-CLD-011019301-101CH2S-P
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3/4"
AWS
011
019004
101CH2S
4"-AWS-011019004-101CH2S-P
3/4"-OLW-011019302-101CS1PN
SA-JER-DS011-TRJR-480046
3/4"
AWS
011
019004
101CH2S
011-LG-0023
4"-AWS-011019004-101CH2S-P
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3/4"
AWS
011
019004
101CH2S
011-LDG-0025
4"-AWS-011019004-101CH2S-P
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3/4"
AWS
011
019006
101CH2S
6"-AWS-011019001-101CH2S-P
011-SC-0028
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3/4"
AWS
011
019008
101CH2S
011-SC-0028
6"-AWS-011019001-101CH2S-P
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
4"
AWS
011
019009
101CH2S
011-D-0004
4"-OLW-011019305-101CS1P-N
-
-
P
25
SOUR WATER
Liquid
981
0.30
65.00
-
-
3.50
100.00
-
H
5.25
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
2"
AWS
011
019010
103CH2S
6"-AWS-011019001-101CH2S-P
011-AT-0019
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
2"
AWS
011
019011
103CH2S
011-AT-0019
6"-AWS-011019001-101CH2S-P
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3/4"
AWS
011
019012
101CH2S
6"-AWS-011019001-101CH2S-P
Reducer
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3/4"
AWS
011
019012
101CH2S
3/4"-AWS-011019012-101CH2SP
Plug
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
2"
AWS
011
019012
101CH2S
Reducer
2"-CLD-011019309-101CH2S-P
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
-
SA-JER-DS011-TRJR-480046
3/4"
AWS
011
019012
101CH2S
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
4"
AWS
011
021001
101CH2S
011-D-0005
Reducer
-
-
N
-
SOUR WATER
Liquid
991
2.60
43.00
-
-
7.00
95.00
-
H
10.50
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
2"
AWS
011
021001
101CH2S
Reducer
Reducer
-
-
N
-
SOUR WATER
Liquid
991
2.60
43.00
-
-
7.00
95.00
-
H
10.50
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480113
4"
AWS
011
021001
101CH2S
SA-JER-DS011-TRJR-480050
011-D-0006
-
-
N
-
SOUR WATER
Liquid
991
1.20
43.00
-
-
5.00
95.00
-
H
7.50
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
4"
AWS
011
021001
101CH2S
Reducer
4"-AWS-011021001-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
991
2.60
43.00
-
-
7.00
95.00
-
H
10.50
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
4"
AWS
011
021001
101CH2S
4"-AWS-011021001-101CH2S-N
SA-JER-DS011-TRJR-480113
-
-
N
-
SOUR WATER
Liquid
991
1.20
43.00
-
-
5.00
95.00
-
H
7.50
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
3/4"
AWS
011
021002
101CH2S
4"-AWS-011021001-101CH2S-N
011-SC-0029
-
-
N
-
SOUR WATER
Liquid
991
2.60
43.00
-
-
7.00
95.00
-
H
10.50
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
3/4"
AWS
011
021003
101CH2S
011-SC-0029
4"-AWS-011021001-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
991
1.20
43.00
-
-
5.00
95.00
-
H
7.50
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
4"
AWS
011
021004
101CH2S
4"-AWS-011021001-101CH2S-N
4"-CLD-011021301-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
991
2.60
43.00
-
-
7.00
95.00
-
H
10.50
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
3/4"
AWS
011
021004
101CH2S
011-LG-0029
4"-AWS-011021004-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
991
2.60
43.00
-
-
7.00
95.00
-
H
10.50
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
6"-AWS-011019001-101CH2S-P 3/4"-AWS-011019012-101CH2S-P
Page 8 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
011-LDG-0031
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480050
3/4"
AWS
011
021004
101CH2S
4"-AWS-011021004-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
991
2.60
43.00
-
-
7.00
95.00
-
H
10.50
D
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480050
4"
AWS
011
021006
101CH2S
011-D-0005
4"-OLW-011021304-101CS1P-N
-
-
N
-
SOUR WATER
Liquid
991
1.80
43.00
-
-
6.00
95.00
-
H
9.00
D
YES
A or Q
N
N
N
Y
N
N
-
-
SA-JER-DS011-TRJR-480050
2"
AWS
011
021008
103CH2S
011-AT-0020
4"-AWS-011021001-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
991
1.20
43.00
-
-
5.00
95.00
-
H
7.50
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
3/4"
AWS
011
021009
101CH2S
4"-AWS-011021001-101CH2S-N
Reducer
-
-
N
-
SOUR WATER
Liquid
991
2.60
43.00
-
-
7.00
95.00
-
H
10.50
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
2"
AWS
011
021009
101CH2S
Reducer
2"-CLD-011021305-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
991
2.60
43.00
-
-
7.00
95.00
-
H
10.50
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
3/4"
AWS
011
021009
101CH2S
4"-AWS-011021001-101CH2S-N
3/4"-AWS-011021009-101CH2SN
-
-
N
-
SOUR WATER
Liquid
991
2.60
43.00
-
-
7.00
95.00
-
H
10.50
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
N
N
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
NOTE 6
if insulated M or Q SA-JER-DS011-TRJR-480050
-
AWS
011
021601
103CH2S
011-D-0005
-
N
-
-
-
-
1.80
43.00
-
-
6.00
-
Visual Test
0.00
D
YES
SA-JER-DS011-TRJR-480082
4"
AWS
011
031001
101CH4S
011-E-0025-A
Reducer
SA-JER-DS011-TRJR-480082
3"
AWS
011
031001
101CH4S
Reducer
SA-JER-DS011-TRJR-480086
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
250.00
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480086
3"
AWS
011
031001
101CH4S
SA-JER-DS011-TRJR-480082
011-D-0008
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
NOTE 6
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480082
4"
AWS
011
031002
101CH4S
011-E-0025-B
Reducer
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
NOTE 6
-1.00
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480082
3"
AWS
011
031002
101CH4S
Reducer
SA-JER-DS011-TRJR-480086
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
NOTE 6
3.50
-1.00
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480086
3"
AWS
011
031002
SA-JER-DS011-TRJR-480083
4"
AWS
011
031003
101CH4S
SA-JER-DS011-TRJR-480082
011-D-0008
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
101CH4S
011-E-0025-C
Reducer
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
NOTE 6
-
3.50
-1.00
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
-
3.50
-1.00
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480083
3"
AWS
011
031003
101CH4S
Reducer
SA-JER-DS011-TRJR-480086
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
NOTE 6
-
-
3.50
-1.00
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480086
3"
AWS
011
031003
101CH4S
SA-JER-DS011-TRJR-480083
011-D-0008
-
-
N
-
SOUR WATER
Liquid
988
0.30
NOTE 6
50.00
-
-
3.50
-1.00
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480083
4"
AWS
011
031004
101CH4S
011-E-0025-D
Reducer
-
-
N
-
SOUR WATER
Liquid
988
NOTE 6
0.30
50.00
-
-
3.50
-1.00
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480083
3"
AWS
011
031004
101CH4S
Reducer
SA-JER-DS011-TRJR-480086
-
-
N
-
SOUR WATER
Liquid
NOTE 6
988
0.30
50.00
-
-
3.50
-1.00
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480086
3"
AWS
011
031004
101CH4S
SA-JER-DS011-TRJR-480083
011-D-0008
-
-
N
-
SOUR WATER
NOTE 6
Liquid
988
0.30
50.00
-
-
3.50
-1.00
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480085
6"
AWS
011
032001
101CH4S
011-E-0026
Reducer
-
-
N
-
SA-JER-DS011-TRJR-480085
4"
AWS
011
032001
101CH4S
Reducer
SA-JER-DS011-TRJR-480086
-
-
N
-
NOTE 6
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480086
4"
AWS
011
032001
101CH4S
SA-JER-DS011-TRJR-480085
011-D-0008
-
-
N
-
NOTE 6
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480085
2"
AWS
011
032002
101CH4S
011-E-0027
Reducer
-
-
N
NOTE 6
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480085
4"
AWS
011
032002
101CH4S
Reducer
Reducer
-
-
NOTE 6
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480086
3"
AWS
011
032002
101CH4S
SA-JER-DS011-TRJR-480085
011-D-0008
-
NOTE 6
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480085
3"
AWS
011
032002
101CH4S
Reducer
SA-JER-DS011-TRJR-480086
NOTE 6
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480085
2"
AWS
011
032003
101CH4S
011-E-0028
SA-JER-DS011-TRJR-480085
4"
AWS
011
032003
101CH4S
NOTE 6
Reducer
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
Reducer
Reducer
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480086
2"
AWS
011
032003
101CH4S
NOTE 6
SA-JER-DS011-TRJR-480085
011-D-0008
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480085
2"
AWS
011
032003
101CH4S
NOTE 6
Reducer
SA-JER-DS011-TRJR-480086
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
250.00
250.00
-
H
5.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480086
8"
AWS
011
033001
NOTE 6
101CH2S
011-D-0008
SA-JER-DS011-TRJR-480088
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
4.20
-1.00
150.00
100.00
-
H
6.30
D
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480088
8"
AWS
011
NOTE 6
033001
101CH2S
SA-JER-DS011-TRJR-480086
Reducer
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
4.20
-1.00
150.00
100.00
-
H
6.30
D
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480088
6"
AWS
NOTE 6
011
033001
101CH2S
Reducer
6"-AWS-011033005-106CH2S-N
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
4.20
-1.00
150.00
100.00
-
H
6.30
D
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480088
8"
SA-JER-DS011-TRJR-480088
6"
NOTE 6
AWS
011
033001
101CH2S
8"-AWS-011033001-101CH2S-N
Reducer
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
4.20
-1.00
150.00
100.00
-
H
6.30
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
AWS
011
033001
101CH2S
Reducer
6"-AWS-011033006-106CH2S-N
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
4.20
-1.00
150.00
100.00
-
H
6.30
D
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480088
NOTE 6
2"
AWS
011
033002
106CH2S
011-G-0019-A
Reducer
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
4"
AWS
011
033002
106CH2S
Reducer
Reducer
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
6"
AWS
011
033002
106CH2S
SA-JER-DS011-TRJR-480088
8"-AWS-011044002-106CH2S-P
-
-
N
-
SOUR WATER
Liquid
988
8.20
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
6"
AWS
011
033002
106CH2S
Reducer
Reducer
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
3"
AWS
011
033002
106CH2S
Reducer
Reducer
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
6"
AWS
011
033002
106CH2S
Reducer
6"-AWS-011033002-106CH2S-N
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
6"
AWS
011
033002
106CH2S
6"-AWS-011033002-106CH2S-N
SA-JER-DS011-TRJR-480114
-
-
N
-
SOUR WATER
Liquid
988
8.20
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
TRIM
-
95.00
if NOT insulated B or Q
SA-JER-DS011-TRJR-480088
3/4"
AWS
011
033002
106CH2S
4"-AWS-011033002-106CH2S-N
3/4"-AWS-011033015-106CH2SN
SA-JER-DS011-TRJR-480088
2"
AWS
011
033003
106CH2S
6"-AWS-011033002-106CH2S-N
SA-JER-DS011-TRJR-480090
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480090
2"
AWS
011
033003
106CH2S
SA-JER-DS011-TRJR-480088
2"-AWS-011034011-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
6"
AWS
011
033005
106CH2S
6"-AWS-011033001-101CH2S-N
Reducer
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
3"
AWS
011
033005
106CH2S
Reducer
011-G-0019-A
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
6"
AWS
011
033006
106CH2S
6"-AWS-011033001-101CH2S-N
Reducer
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
3"
AWS
011
033006
106CH2S
Reducer
011-G-0019-B
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480086
2"
AWS
011
033012
101CH2S
2"-AWS-011034003-101CH2S-N
2"-CLD-011033307-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480086
3/4"
AWS
011
033013
101CH2S
011-LG-0059
Reducer
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
4.20
-1.00
150.00
100.00
-
H
6.30
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480086
3"
AWS
011
033013
101CH2S
Reducer
3"-CLD-011033308-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
4.20
-1.00
150.00
100.00
-
H
6.30
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
2"
AWS
011
033014
106CH2S
011-G-0019-B
Reducer
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
4"
AWS
011
033014
106CH2S
Reducer
Reducer
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
6"
AWS
011
033014
106CH2S
Reducer
6"-AWS-011033002-106CH2S-N
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
3/4"
AWS
011
033014
106CH2S
4"-AWS-011033014-106CH2S-N
3/4"-AWS-011033016-106CH2SN
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
1-1/2"
AWS
011
033015
106CH2S
4"-AWS-011033002-106CH2S-N
Reducer
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
2"
AWS
011
033015
106CH2S
Reducer
2"-CLD-011033309-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
1-1/2"
AWS
011
033015
106CH2S
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
3/4"
AWS
011
033015
106CH2S
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
3/4"
AWS
011
033015
106CH2S
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
1-1/2"
AWS
011
033016
106CH2S
4"-AWS-011033014-106CH2S-N
Reducer
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
2"
AWS
011
033016
106CH2S
Reducer
2"-CLD-011033310-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
1-1/2"
AWS
011
033016
106CH2S
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
3/4"
AWS
011
033016
106CH2S
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
3/4"
AWS
011
033016
106CH2S
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
3/4"
AWS
011
033016
106CH2S
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
3/4"
AWS
011
033017
106CH2S
6"-AWS-011033002-106CH2S-N
011-SC-0021
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
3/4"
AWS
011
033018
106CH2S
011-SC-0021
6"-AWS-011033002-106CH2S-N
-
-
N
-
SOUR WATER
Liquid
988
8.20
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480086
2"
AWS
011
033020
101CH2S
011-D-0008
2"-OLW-011033301-101CS1P-N
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
150.00
100
-
H
5.25
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480086
3"
AWS
011
033022
101CH2S
011-D-0008
3"-OLW-011033022-101CS1P-N
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
150.00
100
-
H
5.25
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480086
2"
AWS
011
033023
101CH2S
UC
011-D-0008
-
-
P
25
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
250.00
100
-
H
5.50
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
ALTERNATE DESIGN CONDITIONS: 7 BARG+FV@290ºC.
-1.00
250.00
100
1-1/2"-AWS-011033015-106CH2SN 1-1/2"-AWS-011033015-106CH2S011-G-0019-A N 3/4"-AWS-011033002-106CH2S- 1-1/2"-AWS-011033015-106CH2SN N 6"-AWS-011033005-106CH2S-N
1-1/2"-AWS-011033016-106CH2SN 3/4"-AWS-011033016-106CH2S011-G-0019-B N 3/4"-AWS-011033016-106CH2S- 1-1/2"-AWS-011033016-106CH2SN N 3/4"-AWS-011033014-106CH2S- 1-1/2"-AWS-011033016-106CH2SN N 6"-AWS-011033006-106CH2S-N
SA-JER-DS011-TRJR-480086
1"
AWS
011
033023
101CH2S
2"-AWS-011033023-101CH2S-P
Blind flange
-
-
P
25
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-
H
5.50
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
ALTERNATE DESIGN CONDITIONS: 7 BARG+FV@290ºC.
SA-JER-DS011-TRJR-480088
3/4"
AWS
011
033024
106CH2S
6"-AWS-011033002-106CH2S-N
Reducer
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
2"
AWS
011
033024
106CH2S
Reducer
2"-CLD-011033312-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
3/4"
AWS
011
033024
106CH2S
6"-AWS-011033002-106CH2S-N
3/4"-AWS-011033024-106CH2SN
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480088
2"
AWS
011
033025
103CH2S
Flange
8"-AWS-011033001-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
4.20
-1.00
150.00
10.00
-
H
6.30
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480086
1"
AWS
011
033301
101CH4S
Reducer
1"-LFL-011033302-101CH2F-N
-
-
N
-
SOUR WATER
Gas
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
D
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480086
3/4"
AWS
011
033301
101CH4S
011-LG-0059
Reducer
-
-
N
-
SOUR WATER
Gas
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
-
-
D
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480086
3/4"
AWS
011
033302
101CH2S
011-LG-0056
3/4"-LFL-011033303-101CH2F-N
-
-
N
-
SOUR WATER
Gas
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
D
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
N
N
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C.
if insulated M or Q SA-JER-DS011-TRJR-480086
-
AWS
011
033601
103CH2S
011-D-0008
SA-JER-DS011-TRJR-480090
1-1/2"
AWS
011
034001
101CH2S
011-J-0004
Reducer
SA-JER-DS011-TRJR-480090
2"
AWS
011
034001
101CH2S
Reducer
SA-JER-DS011-TRJR-480086
SA-JER-DS011-TRJR-380001
TRIM
-
-
N
-
-
-
-
0.30
50.00
-
-
3.50
-1.00
250.00
100.00
-
Visual Test
0.00
NFS
YES
-
-
N
-
SOUR WATER
Liquid
988
1.00
50.00
-
-
3.50
-1.00
90.00
100.00
-
H
5.25
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
-
-
N
-
SOUR WATER
Liquid
988
1.00
50.00
-
-
3.50
-1.00
90.00
100.00
-
H
5.25
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
if NOT insulated B or Q
Page 9 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
TO
011-D-0008
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
2"
AWS
011
034001
101CH2S
SA-JER-DS011-TRJR-480090
-
N
-
SOUR WATER
Liquid
988
1.00
50.00
-
-
3.50
-1.00
90.00
100.00
-
H
5.25
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480090
2"
AWS
011
034002
101CH2S
011-D-0016
Reducer
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
90.00
100.00
-
H
5.25
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480090
1-1/2"
AWS
011
034002
101CH2S
Reducer
011-J-0004
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
90.00
100.00
-
H
5.25
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480089
2"
AWS
011
034003
101CH2S
011-D-0009
SA-JER-DS011-TRJR-480086
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480086
2"
AWS
011
034003
101CH2S
SA-JER-DS011-TRJR-480089
011-D-0008
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480089
2"
AWS
011
034004
101CH2S
011-D-0009
2"-AWS-011034003-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480089
2"
AWS
011
034005
101CH2S
2"-AWS-011034005-101CH2S-N
2"-CLD-011034301-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480089
3/4"
AWS
011
034005
101CH2S
011-LG-0061
2"-AWS-011034005-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480089
2"
AWS
011
034005
101CH2S
2"-AWS-011034003-101CH2S-N
2"-AWS-011034005-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480089
2"
AWS
011
034007
101CH2S
2"-AWS-011034003-101CH2S-N
2"-OLW-011034301-101CS1P-N
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480090
2"
AWS
011
034008
101CH2S
2"-AWS-011034002-101CH2S-N
2"-CLD-011034302-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
90.00
-
H
5.25
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480090
3/4"
AWS
011
034008
101CH2S
011-LG-0098
2"-AWS-011034008-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
90.00
-
H
5.25
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480090
2"
AWS
011
034009
101CH2S
011-D-0016
2"-OLW-011034305-101CS1P-N
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
90.00
-
H
5.25
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480090
2"
AWS
011
034011
101CH2S
2"-AWS-011033003-106CH2S-N
Reducer
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
150.00
-
H
5.25
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480090
1/2"
AWS
011
034011
101CH2S
Reducer
011-J-0004
-
-
N
-
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-
H
5.25
D
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480089
2"
AWS
011
034012
101CH2S
UC
011-D-0009
-
-
P
25
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
D
YES
M
N
N
N
Y
N
N
-
ALTERNATE DESIGN CONDITIONS: 7 BARG+FV@290ºC.
SA-JER-DS011-TRJR-480089
3/4"
AWS
011
034012
101CH2S
2"-AWS-011034012-101CH2S-P
Plug
-
-
P
25
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
D
YES
M
N
N
N
Y
N
N
-
ALTERNATE DESIGN CONDITIONS: 7 BARG+FV@290ºC.
SA-JER-DS011-TRJR-480086
-
INSULATION (NOTE 2)
DOC. No.
150.00
NOTE 6
SA-JER-DS011-TRJR-480090
2"
AWS
011
034013
101CH2S
UC
011-D-0016
-
-
P
25
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
90.00
100.00
-
H
5.25
D
YES
M
N
N
N
Y
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@290ºC.
SA-JER-DS011-TRJR-480090
3/4"
AWS
011
034013
101CH2S
2"-AWS-011034013-101CH2S-P
Blind flange
-
-
P
25
SOUR WATER
Liquid
988
0.30
50.00
-
-
3.50
-1.00
90.00
100.00
-
H
5.25
D
YES
M
N
N
N
Y
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@290ºC.
SA-JER-DS011-TRJR-480090
3/4"
AWS
011
034014
106CH2S
2"-AWS-011033003-106CH2S-N
Reducer
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480090
2"
AWS
011
034014
106CH2S
Reducer
2"-CLD-011034303-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
N
N
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
N
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
N
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
N
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
N
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
if insulated M or Q SA-JER-DS011-TRJR-480089
-
AWS
011
034601
103CH2S
011-D-0009
TRIM
-
-
H
-
-
-
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
Visual Test
0.00
D
YES
SA-JER-DS011-TRJR-480089
2"
AWS
011
034601
103CH2S
011-D-0009
011-LT-0062
-
-
H
25
-
-
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
D
YES
SA-JER-DS011-TRJR-480089
2"
AWS
011
034601
103CH2S
011-D-0009
011-LG-0061
-
-
H
25
-
-
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
D
YES
SA-JER-DS011-TRJR-480089
2"
AWS
011
034601
103CH2S
011-D-0009
011-LG-0061
-
-
H
25
-
-
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
D
YES
SA-JER-DS011-TRJR-480089
2"
AWS
011
034601
103CH2S
011-D-0009
011-LT-0062
-
-
H
25
-
-
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
D
YES
SA-JER-DS011-TRJR-480093
2"
AWS
011
036001
101CH2S
2"-AWS-011036002-101CH4S-N
SA-JER-DS011-TRJR-480086
-
-
N
-
SOUR WATER
Liquid/Gas Mixture
56
0.90
41.00
-
-
4.00
-1.00
250.00
250.00
-
H
6.28
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTES: 6,7.
SA-JER-DS011-TRJR-480086
2"
AWS
011
036001
101CH2S
SA-JER-DS011-TRJR-480093
011-D-0008
-
-
N
-
SOUR WATER
Liquid/Gas Mixture
56
0.90
41.00
-
-
4.00
-1.00
250.00
250.00
-
H
6.28
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480093
2"
AWS
011
036002
101CH4S
011-D-0017
2"-AWS-011036001-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
694
2.10
41.00
-
-
4.00
105.00
-
H
6.00
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480093
1"
AWS
011
036003
101CH4S
2"-AWS-011036002-101CH4S-N
Reducer
-
-
N
-
SOUR WATER
Liquid
694
2.10
41.00
-
-
4.00
105.00
-
H
6.00
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480093
2"
AWS
011
036003
101CH4S
Reducer
2"-CLD-011036302-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
694
2.10
41.00
-
-
4.00
105.00
-
H
6.00
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480093
1"
AWS
011
036003
101CH4S
2"-AWS-011036002-101CH4S-N
1"-AWS-011036003-101CH4S-N
-
-
N
-
SOUR WATER
Liquid
694
2.10
41.00
-
-
4.00
105.00
-
H
6.00
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480093
1"
AWS
011
036004
101CH2S
011-SC-0045
2"-AWS-011036001-101CH2S-N
-
-
N
-
SOUR WATER
Liquid/Gas Mixture
56
0.90
41.00
-
-
4.00
-
H
6.28
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTES: 6,7.
SA-JER-DS011-TRJR-480093
1"
AWS
011
036005
101CH4S
2"-AWS-011036002-101CH4S-N
011-SC-0045
-
-
N
-
SOUR WATER
Liquid
694
2.10
41.00
-
-
4.00
105.00
-
H
6.00
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480093
2"
AWS
011
036006
101CH4S
011-D-0017
2"-OLW-011036302-101CS1P-N
-
-
N
-
SOUR WATER
Liquid
694
2.10
41.00
-
-
4.00
105.00
-
H
6.00
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480093
2"
AWS
011
036007
101CH4S
2"-AWS-011036002-101CH4S-N
2"-CLD-011036301-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
694
2.10
41.00
-
-
4.00
105.00
-
H
6.00
D
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480093
1"
AWS
011
036007
101CH4S
011-LG-0071
2"-AWS-011036007-101CH4S-N
-
-
N
-
SOUR WATER
Liquid
694
2.10
41.00
-
-
4.00
105.00
-
H
6.00
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480093
2"
AWS
011
036009
101CH4S
UC
011-D-0017
-
-
P
25
SOUR WATER
Liquid
694
2.10
41.00
-
-
4.00
105.00
-
H
6.00
D
YES
M
N
N
N
Y
N
N
-
ALTERNATE DESIGN CONDITIONS: 7 barg + FV@290ºC.
SA-JER-DS011-TRJR-480093
1"
AWS
011
036009
101CH4S
2"-AWS-011036009-101CH4S-P
Blind flange
-
-
P
25
SOUR WATER
Liquid
694
2.10
41.00
-
-
4.00
105.00
-
H
6.00
D
YES
M
N
N
N
Y
N
N
-
ALTERNATE DESIGN CONDITIONS: 7 barg + FV@290ºC.
SA-JER-DS011-TRJR-480113
6"
AWS
011
044001
101CH2S
011-D-0006
SA-JER-DS011-TRJR-480114
-
-
P
25
SOUR WATER
Liquid
980
0.30
62.00
-
-
5.50
110.00
-
H
8.25
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
6"
AWS
011
044001
101CH2S
SA-JER-DS011-TRJR-480113
6"-AWS-011044004-106CH2S-P
-
-
P
25
SOUR WATER
Liquid
980
0.30
62.00
-
-
5.50
110.00
-
H
8.25
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
6"
AWS
011
044001
101CH2S
6"-AWS-011044001-101CH2S-P
6"-AWS-011044003-106CH2S-P
-
-
P
25
SOUR WATER
Liquid
980
0.30
62.00
-
-
5.50
110.00
-
H
8.25
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
2"
AWS
011
044002
106CH2S
011-G-0006-A
Reducer
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3/4"
AWS
011
044002
106CH2S
8"-AWS-011044002-106CH2S-P
011-PI-0163
-
-
P
25
SOUR WATER
Liquid
980
7.90
62.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
6"
AWS
011
044002
106CH2S
Reducer
6"-AWS-011044002-106CH2S-P
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
3/4"
AWS
011
044002
106CH2S
6"-AWS-011044002-106CH2S-P
011-PI-0123
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
8"
AWS
011
044002
106CH2S
SA-JER-DS011-TRJR-480114
IP-1308-L
-
-
P
25
SOUR WATER
Liquid
980
7.90
62.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3/4"
AWS
011
044002
106CH2S
8"-AWS-011044002-106CH2S-P
Blind flange
-
-
P
25
SOUR WATER
Liquid
980
7.90
62.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
6"
AWS
011
044002
106CH2S
6"-AWS-011044002-106CH2S-P
Reducer
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
2"
AWS
011
044002
106CH2S
6"-AWS-011044002-106CH2S-P
011-TT-0368
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
1/2"
AWS
011
044002
106CH2S
011-FE-0115
011-FT-0115
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
3"
AWS
011
044002
106CH2S
Reducer
3"-AWS-011044002-106CH2S-P
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
1/2"
AWS
011
044002
106CH2S
011-FE-0115
011-FT-0115
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
4"
AWS
011
044002
106CH2S
6"-AWS-011044002-106CH2S-P
Reducer
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
3"
AWS
011
044002
106CH2S
Reducer
Reducer
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
6"
AWS
011
044002
106CH2S
Reducer
6"-AWS-011044002-106CH2S-P
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
6"
AWS
011
044002
106CH2S
6"-AWS-011044002-106CH2S-P
Reducer
-
-
P
25
SOUR WATER
Liquid
980
7.90
62.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
4"
AWS
011
044002
106CH2S
Reducer
6"-AWS-011044002-106CH2S-P
-
-
P
25
SOUR WATER
Liquid
980
7.90
62.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
3"
AWS
011
044002
106CH2S
3"-AWS-011044002-106CH2S-P
Reducer
-
-
P
25
SOUR WATER
Liquid
980
7.90
62.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
8"
AWS
011
044002
106CH2S
Reducer
SA-JER-DS011-TRJR-480132
-
-
P
25
SOUR WATER
Liquid
980
7.90
62.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
6"
AWS
011
044003
106CH2S
6"-AWS-011044001-101CH2S-P
Reducer
-
-
P
25
SOUR WATER
Liquid
980
0.30
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
3/4"
AWS
011
044003
106CH2S
6"-AWS-011044003-106CH2S-P
UC
-
-
P
25
SOUR WATER
Liquid
980
0.30
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
3/4"
AWS
011
044003
106CH2S
6"-AWS-011044003-106CH2S-P
011-PI-0187
-
-
P
25
SOUR WATER
Liquid
980
0.30
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
3"
AWS
011
044003
106CH2S
Reducer
011-G-0006-A
-
-
P
25
SOUR WATER
Liquid
980
0.30
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
6"-AWS-011044001-101CH2S-P
Reducer
-
-
P
25
SOUR WATER
Liquid
980
0.30
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
-
P
25
980
0.30
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
-1.00
250.00
100.00
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
NOTE 6
SA-JER-DS011-TRJR-480114
6"
AWS
011
044004
106CH2S
SA-JER-DS011-TRJR-480114
3/4"
AWS
011
044004
106CH2S
6"-AWS-011044004-106CH2S-P
UC
-
SOUR WATER
Liquid
SA-JER-DS011-TRJR-480114
3/4"
AWS
011
044004
106CH2S
6"-AWS-011044004-106CH2S-P
011-PI-0190
-
-
P
25
SOUR WATER
Liquid
980
0.30
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
3"
AWS
011
044004
106CH2S
Reducer
011-G-0006-B
-
-
P
25
SOUR WATER
Liquid
980
0.30
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480113
3/4"
AWS
011
044005
101CH2S
011-LG-0079
3"-AWS-011044017-101CH2S-P
-
-
P
25
SOUR WATER
Liquid
980
0.30
62.00
-
-
5.50
110.00
-
H
8.25
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
1-1/2"
AWS
011
044008
106CH2S
6"-AWS-011044002-106CH2S-P
Reducer
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
3/4"-OLW-011044302-101CS1PN
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
3/4"
AWS
011
044008
106CH2S
1-1/2"-AWS-011044008106CH2S-P
SA-JER-DS011-TRJR-480114
2"
AWS
011
044008
106CH2S
Reducer
2"-CLD-011044302-101CH2S-N
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
1-1/2"
AWS
011
044008
106CH2S
6"-AWS-011044003-106CH2S-P
1-1/2"-AWS-011044008-106CH2SP
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
3/4"
AWS
011
044008
106CH2S
011-G-0006-A
Reducer
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
1"
AWS
011
044008
106CH2S
Reducer
1-1/2"-AWS-011044008-106CH2SP
-
-
P
25
SOUR WATER
Liquid
988
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
1-1/2"
AWS
011
044009
106CH2S
6"-AWS-011044015-106CH2S-P
Reducer
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 10 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480114
3/4"
AWS
011
044009
106CH2S
1-1/2"-AWS-011044009106CH2S-P
3/4"-OLW-011044303-101CS1PN
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
2"
AWS
011
044009
106CH2S
Reducer
2"-CLD-011044303-101CH2S-N
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
1-1/2"
AWS
011
044009
106CH2S
6"-AWS-011044004-106CH2S-P
1-1/2"-AWS-011044009-106CH2SP
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
3/4"
AWS
011
044009
106CH2S
011-G-0006-B
Reducer
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
1"
AWS
011
044009
106CH2S
Reducer
1-1/2"-AWS-011044009-106CH2SP
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
3/4"
AWS
011
044010
106CH2S
6"-AWS-011044002-106CH2S-P
011-SC-0004
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
3/4"
AWS
011
044011
106CH2S
011-SC-0004
6"-AWS-011044002-106CH2S-P
-
-
P
25
SOUR WATER
Liquid
980
7.90
62.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480113
2"
AWS
011
044012
101CH2S
011-D-0006
2"-OLW-011044304-101CS1P-N
-
-
P
25
WATER
Liquid
1000
0.30
62.00
-
-
6.00
110.00
-
H
9.00
ASME N/A
YES
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480113
3/4"
AWS
011
044013
101CH2S
011-LG-0079
3/4"-LFL-011044301-101CH2F-N
-
-
P
25
SOUR WATER
Gas
-
0.30
62.00
-
-
5.50
110.00
-
H
8.25
D
YES
M
N
N
N
Y
N
N
-
-
Blind flange
-
-
P
25
SOUR WATER
Gas
-
0.30
62.00
-
-
5.50
110.00
-
H
8.25
D
YES
M
N
N
N
Y
N
N
-
-
011-D-0006
-
-
P
25
SOUR WATER
Liquid
980
0.30
62.00
-
-
5.00
110.00
-
H
7.50
D
YES
M
N
N
N
Y
N
N
-
ALTERNATE DESIGN CONDITIONS:7 BARG+FV @290ºC.
SA-JER-DS011-TRJR-480113
3/4"
AWS
011
044013
101CH2S
3/4"-AWS-011044013-101CH2SP
SA-JER-DS011-TRJR-480113
2"
AWS
011
044014
101CH2S
UC
SA-JER-DS011-TRJR-480113
3/4"
AWS
011
044014
101CH2S
2"-AWS-011044014-101CH2S-P
Plug
-
-
P
25
SOUR WATER
Liquid
980
0.30
62.00
-
-
5.00
110.00
-
H
7.50
D
YES
M
N
N
N
Y
N
N
-
ALTERNATE DESIGN CONDITIONS:7 BARG+FV @290ºC.
SA-JER-DS011-TRJR-480114
2"
AWS
011
044015
106CH2S
011-G-0006-B
Reducer
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
6"
AWS
011
044015
106CH2S
Reducer
6"-AWS-011044015-106CH2S-P
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
3/4"
AWS
011
044015
106CH2S
6"-AWS-011044015-106CH2S-P
011-PI-0124
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
6"
AWS
011
044015
106CH2S
6"-AWS-011044015-106CH2S-P
6"-AWS-011044002-106CH2S-P
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
3/4"
AWS
011
044016
106CH2S
6"-AWS-011044002-106CH2S-P
Reducer
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
3/4"
AWS
011
044016
106CH2S
3/4"-AWS-011044016-106CH2SP
Blind flange
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
2"
AWS
011
044016
106CH2S
Reducer
2"-CLD-011044304-101CH2S-N
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480114
3/4"
AWS
011
044016
106CH2S
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480113
3"
AWS
011
044017
101CH2S
011-D-0006
SA-JER-DS011-TRJR-480046
-
-
P
25
SOUR WATER
Liquid
980
0.30
62.00
-
-
5.50
110.00
-
H
8.25
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3"
AWS
011
044017
101CH2S
SA-JER-DS011-TRJR-480113
4"-AWS-011019004-101CH2S-P
-
-
P
25
SOUR WATER
Liquid
980
0.30
62.00
-
-
5.50
110.00
-
H
8.25
D
YES
M
N
N
N
Y
N
N
-
NOTE 6
N
N
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
N
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
N
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
N
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
N
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
N
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
N
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
N
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
6"-AWS-011044002-106CH2S-P 3/4"-AWS-011044016-106CH2S-P
if insulated M or Q SA-JER-DS011-TRJR-480113
-
AWS
011
044601
103CH2S
011-D-0006
TRIM
-
-
P
-
-
-
-
0.30
62.00
-
-
5.00
110.00
-
Visual Test
0.00
D
YES
SA-JER-DS011-TRJR-480113
2"
AWS
011
044601
103CH2S
011-D-0006
011-LG-0079
-
-
P
25
-
-
-
0.30
62.00
-
-
5.00
110.00
-
H
7.50
D
YES
SA-JER-DS011-TRJR-480113
1/4"
AWS
011
044601
103CH2S
011-D-0006
011-LT-0107
-
-
P
25
-
-
-
0.30
62.00
-
-
5.00
110.00
-
-
-
D
YES
SA-JER-DS011-TRJR-480113
2"
AWS
011
044601
103CH2S
011-D-0006
011-PI-0320
-
-
P
25
-
-
-
0.30
62.00
-
-
5.00
110.00
-
H
7.50
D
YES
SA-JER-DS011-TRJR-480113
2"
AWS
011
044601
103CH2S
011-D-0006
011-LT-0080
-
-
P
25
-
-
-
0.30
62.00
-
-
5.00
110.00
-
H
7.50
D
YES
SA-JER-DS011-TRJR-480113
2"
AWS
011
044601
103CH2S
011-D-0006
011-LT-0107
-
-
P
25
-
-
-
0.30
62.00
-
-
5.00
110.00
-
H
7.50
D
YES
SA-JER-DS011-TRJR-480113
2"
AWS
011
044601
103CH2S
011-D-0006
011-LT-0080
-
-
P
25
-
-
-
0.30
62.00
-
-
5.00
110.00
-
H
7.50
D
YES
SA-JER-DS011-TRJR-480113
2"
AWS
011
044601
103CH2S
011-D-0006
011-LG-0079
-
-
P
25
-
-
-
0.30
62.00
-
-
5.00
110.00
-
H
7.50
D
YES
SA-JER-DS011-TRJR-480132
3/4"
AWS
011
098001
106CH2S
8"-AWS-011044002-106CH2S-P
Reducer
-
-
P
25
SOUR WATER
Liquid
980
7.90
62.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3/4"
AWS
011
098001
106CH2S
3/4"-AWS-011098001-106CH2SP
Blind flange
-
-
P
25
SOUR WATER
Liquid
980
7.90
62.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
2"
AWS
011
098001
106CH2S
Reducer
2"-CLD-011098326-101CH2S-P
-
-
P
25
SOUR WATER
Liquid
980
7.90
62.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3/4"
AWS
011
098001
106CH2S
-
-
P
25
SOUR WATER
Liquid
980
7.90
62.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480105
2"
BDH
011
040001
101CS1P
011-D-0011
Reducer
-
-
P
25
WATER
Liquid
958
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
1-1/2"
BDH
011
040001
101CS1P
Reducer
011-SP-0045
-
-
P
25
WATER
Liquid
958
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
1-1/2"
BDH
011
040001
101CS1P
011-SP-0045
Reducer
-
-
P
25
WATER
Liquid
958
0.30
107.00
-
-
3.50
-1.00
135.00
170.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
2"
BDH
011
040001
101CS1P
Reducer
011-D-0013
-
-
P
25
WATER
Liquid
958
0.30
107.00
-
-
3.50
-1.00
135.00
170.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480105
2"
BDH
011
040002
101CS1P
011-D-0011
011-SP-0001
-
-
P
25
WATER
Liquid
958
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
2"
BDH
011
040002
101CS1P
011-SP-0001
2"-BDH-011040001-101CS1P-P
-
-
P
25
WATER
Liquid
958
0.30
107.00
-
-
3.50
-1.00
135.00
170.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
3/4"
BDH
011
040003
101CS1P
2"-BDH-011040002-101CS1P-P
011-SC-0022
-
-
P
25
WATER
Liquid
958
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
3/4"
BDH
011
040003
101CS1P
2"-BDH-011040002-101CS1P-P
SAMPLE COOLER
-
-
P
25
WATER
Liquid
958
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M
N
N
N
N
N
N
-
BDH
011
040004
-
-
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
M
N
N
N
N
N
N
-
-
THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. -
101CS1P
011-D-0011
2"-OLW-011040305-101CS1P-N
P
25
WATER
Liquid
958
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
SA-JER-DS011-TRJR-480105
2"
BDH
011
040005
101CS1P
011-D-0013
2"-OLW-011040306-101CS1P-N
-
-
P
25
WATER
Liquid
958
0.30
107.00
-
-
3.50
-1.00
135.00
170.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
3/4"
BDH
011
200001
101CS1P
SAMPLE COOLER
Reducer
-
-
N
-
WATER
Liquid
983
2.60
60.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
4"
BDH
011
200001
101CS1P
Reducer
Reducer
-
-
N
-
WATER
Liquid
983
2.60
60.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
3/4"
BDH
011
200001
101CS1P
Reducer
170.00
SA-JER-DS011-TRJR-480274
3/4"
BDH
011
200002
101CS1P 3/4"-BDH-011200001-101CS1P-N
SA-JER-DS011-TRJR-480274
2"
BDH
011
200002
101CS1P
SA-JER-DS011-TRJR-480042
1"
BFW
011
017002
SA-JER-DS011-TRJR-480042
1-1/2"
BFW
011
SA-JER-DS011-TRJR-480204
1"
BFW
011
SA-JER-DS011-TRJR-480042
1"
BFW
SA-JER-DS011-TRJR-480042
1"
SA-JER-DS011-TRJR-480042
SA-JER-DS011-TRJR-480105
2"
8"-AWS-011044002-106CH2S-P 3/4"-AWS-011098001-106CH2S-P
if NOT insulated B or Q if insulated M or Q
SO
-
-
N
-
WATER
Liquid
983
2.60
60.00
-
-
7.00
-1.00
170.00
-
H
10.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
Reducer
-
-
N
-
WATER
Liquid
983
2.60
60.00
-
-
7.00
-1.00
170.00
-
H
10.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
Reducer
2"-CLD-011200317-101CH2S-P
-
-
N
-
WATER
Liquid
983
2.60
60.00
-
-
7.00
-1.00
170.00
-
H
10.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
103CJ1P
1"-BFW-011017301-101CS1P-H
Reducer
-
-
H
25
BOILER FEED WATER
Liquid
958
3.50
105.00
-
-
7.00
-1.00
440.00
-
H
14.23
NFS
YES
M or Q
N
N
N
N
N
N
-
-
017002
103CJ1P
Reducer
011-DS-0001
-
-
H
25
BOILER FEED WATER
Liquid
958
3.50
105.00
-
-
7.00
-1.00
440.00
-
H
14.23
NFS
YES
M or Q
N
N
N
N
N
N
-
-
017301
101CS1P
6"-BFW-011071301-101CS1P-H
SA-JER-DS011-TRJR-480042
-
-
H
25
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
011
017301
101CS1P
SA-JER-DS011-TRJR-480204
1"-BFW-011017002-103CJ1P-H
-
-
H
25
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
BFW
011
017301
101CS1P
1"-BFW-011017301-101CS1P-H
1"-BFW-011017301-101CS1P-H
-
-
H
25
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
3/4"
BFW
011
017301
101CS1P
1"-BFW-011017301-101CS1P-H
Plug
-
-
H
25
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480042
3/4"
BFW
011
017301
101CS1P
1"-BFW-011017301-101CS1P-H
Plug
-
-
H
25
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480203
1"
BFW
011
029301
101CS1P
6"-BFW-011071301-101CS1P-H
SA-JER-DS011-TRJR-480079
-
-
H
25
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480203
1"-BFW-011029302-103CJ1P-H
-
-
H
25
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
-
H
25
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480079
1"
BFW
011
029301
101CS1P
SA-JER-DS011-TRJR-480079
3/4"
BFW
011
029301
101CS1P
1"-BFW-011029301-101CS1P-H
Plug
-
BOILER FEED WATER
Liquid
SA-JER-DS011-TRJR-480079
3/4"
BFW
011
029301
101CS1P
1"-BFW-011029301-101CS1P-H
Plug
-
-
H
25
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480079
1"
BFW
011
029301
101CS1P
1"-BFW-011029301-101CS1P-H
1"-BFW-011029301-101CS1P-H
-
-
H
25
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480079
1"
BFW
011
029302
103CJ1P
1"-BFW-011029301-101CS1P-H
Reducer
-
-
H
25
BOILER FEED WATER
Liquid
958
2.25
105.00
-
-
7.00
-1.00
437.00
437.00
-
H
14.17
NFS
YES
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480079
1-1/2"
BFW
011
029302
103CJ1P
Reducer
011-DS-0002
-
-
H
25
BOILER FEED WATER
Liquid
958
2.25
105.00
-
-
7.00
-1.00
437.00
437.00
-
H
14.17
NFS
YES
M or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480105
6"
BFW
011
040001
101CS1P
011-D-0011
SA-JER-DS011-TRJR-480104
-
-
H
50
BOILER FEED WATER
Liquid
923
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480104
6"
BFW
011
040001
101CS1P
SA-JER-DS011-TRJR-480105
6"-BFW-011040001-101CS1P-H
-
-
H
50
BOILER FEED WATER
Liquid
923
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480104
6"
BFW
011
040001
101CS1P
6"-BFW-011040001-101CS1P-H
011-E-0031-A
-
-
H
50
BOILER FEED WATER
Liquid
923
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
Page 11 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
FLUID CATEGORY (ASME B.31.3)
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6)
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
6"
BFW
011
040002
101CS1P
011-D-0011
SA-JER-DS011-TRJR-480104
-
H
50
BOILER FEED WATER
Liquid
923
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
N
-
-
SA-JER-DS011-TRJR-480104
6"
BFW
011
040002
101CS1P
SA-JER-DS011-TRJR-480105
6"-BFW-011040002-101CS1P-H
-
-
H
50
BOILER FEED WATER
Liquid
923
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480104
6"
BFW
011
040002
101CS1P
6"-BFW-011040002-101CS1P-H
011-E-0031-B
-
-
H
50
BOILER FEED WATER
Liquid
923
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480104
3/4"
BFW
011
040003
101CS1P
6"-BFW-011040001-101CS1P-H
-
-
H
25
BOILER FEED WATER
Liquid
923
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480104
3/4"
BFW
011
040004
101CS1P
6"-BFW-011040002-101CS1P-H
-
-
H
25
BOILER FEED WATER
Liquid
923
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480104
3/4"
BFW
011
040007
101CS1P
6"-BFW-011040001-101CS1P-H
-
-
H
25
BOILER FEED WATER
Liquid
923
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480104
3/4"
BFW
011
040008
101CS1P
6"-BFW-011040002-101CS1P-H
-
-
H
25
BOILER FEED WATER
Liquid
923
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480206
3"
BFW
011
040301
101CS1P
6"-BFW-011071301-101CS1P-H
SA-JER-DS011-TRJR-480105
-
-
H
40
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
3"
BFW
011
040301
101CS1P
SA-JER-DS011-TRJR-480206
Reducer
-
-
H
40
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
3"
BFW
011
040301
101CS1P
3"-BFW-011040301-101CS1P-H
Reducer
-
-
H
40
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
1"
BFW
011
040301
101CS1P
Reducer
1"-BFW-011040302-101CS1P-P
-
-
H
25
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
3/4"
BFW
011
040301
101CS1P
3"-BFW-011040301-101CS1P-H
Plug
-
-
H
25
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
1-1/2"
BFW
011
040301
101CS1P
Reducer
Reducer
-
-
H
25
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
3"
BFW
011
040301
101CS1P
Reducer
3"-BFW-011040302-101CS1P-P
-
-
H
40
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
3/4"
BFW
011
040301
101CS1P
3"-BFW-011040301-101CS1P-H
Plug
-
-
H
25
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
3"
BFW
011
040302
101CS1P
3"-BFW-011040301-101CS1P-H
011-D-0011
-
-
P
25
BOILER FEED WATER
Liquid
923
2.60
140.00
-
-
7.00
-1.00
170.00
170
-
H
10.50
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
3"
BFW
011
040302
101CS1P
Reducer
3"-BFW-011040302-101CS1P-P
-
-
P
25
BOILER FEED WATER
Liquid
923
2.60
140.00
-
-
7.00
-1.00
170.00
170
-
H
10.50
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
1"
BFW
011
040302
101CS1P
1"-BFW-011040301-101CS1P-H
Reducer
-
-
P
25
BOILER FEED WATER
Liquid
923
2.60
140.00
-
-
7.00
-1.00
170.00
170
-
H
10.50
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
3"
BFW
011
040302
101CS1P
3"-BFW-011040301-101CS1P-H
3"-BFW-011040302-101CS1P-P
-
-
P
25
BOILER FEED WATER
Liquid
923
2.60
140.00
-
-
7.00
-1.00
170.00
170
-
H
10.50
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
6"
BFW
011
043301
101CS1P
6"-BFW-011071301-101CS1P-H
SA-JER-DS011-TRJR-480112
-
-
H
50
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
150.00
D
SA-JER-DS011-TRJR-380001
SA-JER-DS011-TRJR-480105
3/4"-OLW-011040302-101CS1PN 3/4"-OLW-011040303-101CS1PN 3/4"-OLW-011040308-101CS1PN 3/4"-OLW-011040309-101CS1PN
-
INSULATION (NOTE 2)
DOC. No.
By Code
M or Q
N
N
N
N
N
SA-JER-DS011-TRJR-480112
6"
BFW
011
043301
101CS1P
SA-JER-DS011-TRJR-480202
Reducer
-
-
H
50
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
1/2"
BFW
011
043301
101CS1P
011-FE-0059
011-FT-0059-A
-
-
H
25
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
3"
BFW
011
043301
101CS1P
Reducer
3"-BFW-011043301-101CS1P-H
-
-
H
40
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
3/4"
BFW
011
043301
101CS1P
6"-BFW-011043301-101CS1P-H
Plug
-
-
H
25
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
6"
BFW
011
043301
101CS1P
6"-BFW-011043301-101CS1P-H
Reducer
-
-
H
50
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
1/2"
BFW
011
043301
101CS1P
011-FE-0059
011-FT-0059-A
-
-
H
25
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
4"
BFW
011
043301
101CS1P
Reducer
Reducer
-
-
H
40
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
6"
BFW
011
043301
101CS1P
Reducer
6"-BFW-011043301-101CS1P-H
-
-
H
50
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
3/4"
BFW
011
043301
101CS1P
6"-BFW-011043301-101CS1P-H
Plug
-
-
H
25
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
6"
BFW
011
043301
101CS1P
6"-BFW-011043301-101CS1P-H
011-D-0007
-
-
H
50
BOILER FEED WATER
Liquid
923
1.00
105.00
-
-
3.50
150.00
-
H
5.25
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
3"
BFW
011
043301
101CS1P
3"-BFW-011043301-101CS1P-H
Reducer
-
-
H
40
BOILER FEED WATER
Liquid
923
1.00
105.00
-
-
3.50
150.00
-
H
5.25
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
6"
BFW
011
043301
101CS1P
Reducer
6"-BFW-011043301-101CS1P-H
-
-
H
50
BOILER FEED WATER
Liquid
923
1.00
105.00
-
-
3.50
150.00
-
H
5.25
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480122
2"
BFW
011
052001
101CS1P
2"-BFW-011052301-101CS1P-H
2"-PRW-011052001-101CS2P-H
-
-
H
40
BOILER FEED WATER
Liquid
923
1.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480122
1"
BFW
011
052001
101CS1P
1"-BFW-011052301-101CS1P-H
Reducer
-
-
H
25
BOILER FEED WATER
Liquid
923
1.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480206
2"
BFW
011
052301
101CS1P
6"-BFW-011071301-101CS1P-H
SA-JER-DS011-TRJR-480122
-
-
H
40
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480122
2"
BFW
011
052301
101CS1P
SA-JER-DS011-TRJR-480206
Reducer
-
-
H
40
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480122
1"
BFW
011
052301
101CS1P
Reducer
1"-BFW-011052001-101CS1P-H
-
-
H
25
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480122
2"
BFW
011
052301
101CS1P
2"-BFW-011052301-101CS1P-H
Reducer
-
-
H
40
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480122
3/4"
BFW
011
052301
101CS1P
2"-BFW-011052301-101CS1P-H
Plug
-
-
H
25
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480122
1"
BFW
011
052301
101CS1P
Reducer
Reducer
-
-
H
25
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480122
2"
BFW
011
052301
101CS1P
Reducer
2"-BFW-011052001-101CS1P-H
-
-
H
40
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480122
3/4"
BFW
011
052301
101CS1P
2"-BFW-011052301-101CS1P-H
Plug
-
-
H
25
BOILER FEED WATER
Liquid
923
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
6"
BFW
011
071001
101CS1P
011-PZV-0062-A
Reducer
-
-
P
25
BOILER FEED WATER
Liquid
958
0.00
27.00
-
-
0.00
128.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
8"
BFW
011
071001
101CS1P
Reducer
20"-BFW-011071001-101CS1P-P
-
-
P
25
BOILER FEED WATER
Liquid
958
0.00
27.00
-
-
0.00
128.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071001
101CS1P
8"-BFW-011071001-101CS1P-P
Plug
-
-
P
25
BOILER FEED WATER
Liquid
958
0.00
27.00
-
-
0.00
128.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
20"
BFW
011
071001
101CS1P
HEADER
HEADER
-
-
P
25
BOILER FEED WATER
Liquid
958
0.00
27.00
-
-
0.00
128.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
6"
BFW
011
071001
101CS1P
011-PZV-0062-B
Reducer
-
-
P
25
BOILER FEED WATER
Liquid
958
0.00
27.00
-
-
0.00
128.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
8"
BFW
011
071001
101CS1P
Reducer
8"-BFW-011071001-101CS1P-P
-
-
P
25
BOILER FEED WATER
Liquid
958
0.00
27.00
-
-
0.00
128.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071001
101CS1P
8"-BFW-011071001-101CS1P-P
Plug
-
-
P
25
BOILER FEED WATER
Liquid
958
0.00
27.00
-
-
0.00
128.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
2"
BFW
011
071001
101CS1P
2"-BFW-011071303-101CS1P-H
8"-BFW-011071001-101CS1P-P
-
-
P
25
BOILER FEED WATER
Liquid
958
0.00
27.00
-
-
0.00
128.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
6"
BFW
011
071301
101CS1P
6"-BFW-011071312-106CS1P-H
SA-JER-DS011-TRJR-480206
-
-
H
50
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
2"
BFW
011
071301
101CS1P
2"-BFW-011071312-106CS1P-H
Reducer
-
-
H
40
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
6"
BFW
011
071301
101CS1P
Reducer
6"-BFW-011071301-101CS1P-H
-
-
H
50
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071301
101CS1P
6"-BFW-011071301-101CS1P-H
011-PT-0417
-
-
H
25
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
6"
BFW
011
071301
101CS1P
6"-BFW-011071301-101CS1P-H
SA-JER-DS011-TRJR-480204
-
-
H
50
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480206
6"
BFW
011
071301
101CS1P
SA-JER-DS011-TRJR-480202
HEADER
-
-
H
50
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480204
6"
BFW
011
071301
101CS1P
SA-JER-DS011-TRJR-480202
SA-JER-DS011-TRJR-480313
-
-
H
50
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480313
6"
BFW
011
071301
101CS1P
SA-JER-DS011-TRJR-480204
SA-JER-DS011-TRJR-480205
-
-
H
50
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480205
6"
BFW
011
071301
101CS1P
SA-JER-DS011-TRJR-480313
SA-JER-DS011-TRJR-480203
-
-
H
50
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480203
6"
BFW
011
071301
101CS1P
SA-JER-DS011-TRJR-480205
HEADER
-
-
H
50
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
2"
BFW
011
071302
106CS1P
6"-BFW-011071312-106CS1P-H
Reducer
-
-
H
40
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
-1.00
150.00
350.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071302
106CS1P
1"-BFW-011071302-106CS1P-H
Blind flange
-
-
H
25
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
-1.00
150.00
350.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071302
106CS1P
1"-BFW-011071302-106CS1P-H
Blind flange
-
-
H
25
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
-1.00
150.00
350.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
1"
BFW
011
071302
106CS1P
Reducer
1"-BFW-011071302-106CS1P-H
-
-
H
25
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
-1.00
150.00
350.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
1"
BFW
011
071302
106CS1P
1"-BFW-011071302-106CS1P-H
011-RO-0072
-
-
H
25
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
-1.00
150.00
350.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
1"
BFW
011
071302
106CS1P
1"-BFW-011071302-106CS1P-H
1"-BFW-011071305-103CS1P-H
-
-
H
25
BOILER FEED WATER
Liquid
955
19.00
105.00
-
-
90.00
-1.00
150.00
350.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
1"
BFW
011
071302
106CS1P
011-RO-0072
1"-BFW-011071302-106CS1P-H
-
-
H
25
BOILER FEED WATER
Liquid
955
19.00
105.00
-
-
90.00
-1.00
150.00
350.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
6"
BFW
011
071303
101CS1P
6"-BFW-011071301-101CS1P-H
Reducer
-
-
H
50
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071303
101CS1P
6"-BFW-011071303-101CS1P-H
Plug
-
-
H
25
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
4"
BFW
011
071303
101CS1P
Reducer
011-PZV-0062-A
-
-
H
40
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
6"
BFW
011
071303
101CS1P
6"-BFW-011071303-101CS1P-H
Reducer
-
-
H
50
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
2"
BFW
011
071303
101CS1P
6"-BFW-011071303-101CS1P-H
2"-BFW-011071001-101CS1P-P
-
-
H
40
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071303
101CS1P
6"-BFW-011071303-101CS1P-H
Plug
-
-
H
25
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071303
101CS1P
2"-BFW-011071303-101CS1P-H
Plug
-
-
H
25
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
4"
BFW
011
071303
101CS1P
Reducer
011-PZV-0062-B
-
-
H
40
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071304
101CS1P
6"-BFW-011071301-101CS1P-H
011-SC-0049
-
-
H
25
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480274
3/4"
BFW
011
071304
101CS1P
6"-BFW-011071301-101CS1P-H
SAMPLE COOLER
-
-
H
25
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480202
1-1/2"
BFW
011
071305
103CS1P
Reducer
011-DS-0003
-
-
H
25
BOILER FEED WATER
Liquid
955
19.00
105.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
M or Q
N
N
N
N
N
N
-
THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. -
SA-JER-DS011-TRJR-480202
1"
BFW
011
071305
103CS1P
1"-BFW-011071302-106CS1P-H
Reducer
-
-
H
25
BOILER FEED WATER
Liquid
955
19.00
105.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
2"
BFW
011
071306
101CS1P
2"-BFW-011071313-106CS1P-H
6"-BFW-011071301-101CS1P-H
-
-
H
40
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
1/2"
BFW
011
071306
101CS1P
1/2"-BFW-011071313-106CS1PH
Reducer
-
-
H
25
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
2"
BFW
011
071306
101CS1P
Reducer
2"-BFW-011071306-101CS1P-H
-
-
H
40
BOILER FEED WATER
Liquid
958
12.00
105.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
2"
BFW
011
071310
103CS1P
1-1/2"-BFW-011071305-103CS1PH
Reducer
-
-
H
40
BOILER FEED WATER
Liquid
958
19.00
105.00
-
-
19.00
350.00
-
H
33.77
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071310
103CS1P
2"-BFW-011071310-103CS1P-H
Plug
-
-
H
25
BOILER FEED WATER
Liquid
958
19.00
105.00
-
-
19.00
350.00
-
H
33.77
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
1"
BFW
011
071310
103CS1P
Reducer
011-PZV-0094-A
-
-
H
25
BOILER FEED WATER
Liquid
958
19.00
105.00
-
-
19.00
350.00
-
H
33.77
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
2"
BFW
011
071310
103CS1P
2"-BFW-011071310-103CS1P-H
Reducer
-
-
H
40
BOILER FEED WATER
Liquid
958
19.00
105.00
-
-
19.00
350.00
-
H
33.77
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071310
103CS1P
2"-BFW-011071310-103CS1P-H
Plug
-
-
H
25
BOILER FEED WATER
Liquid
958
19.00
105.00
-
-
19.00
350.00
-
H
33.77
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
1"
BFW
011
071310
103CS1P
Reducer
011-PZV-0094-B
-
-
H
25
BOILER FEED WATER
Liquid
958
19.00
105.00
-
-
19.00
350.00
-
H
33.77
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
2"
BFW
011
071310
103CS1P
2"-BFW-011071310-103CS1P-H
2"-BFW-011071311-101CS1P-P
-
-
H
40
BOILER FEED WATER
Liquid
958
19.00
105.00
-
-
19.00
350.00
-
H
33.77
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-380001
-
Page 12 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6)
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071310
103CS1P
2"-BFW-011071310-103CS1P-H
Plug
-
-
H
25
BOILER FEED WATER
Liquid
958
19.00
105.00
-
-
19.00
350.00
-
H
33.77
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
2"
BFW
011
071311
101CS1P
011-PZV-0094-A
Reducer
-
-
P
25
BOILER FEED WATER
Liquid
958
0.00
27.00
-
-
0.00
128.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
3"
BFW
011
071311
101CS1P
Reducer
6"-BFW-011071311-101CS1P-P
-
-
P
25
BOILER FEED WATER
Liquid
958
0.00
27.00
-
-
0.00
128.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071311
101CS1P
3"-BFW-011071311-101CS1P-P
Plug
-
-
P
25
BOILER FEED WATER
Liquid
958
0.00
27.00
-
-
0.00
128.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071311
101CS1P
3"-BFW-011071311-101CS1P-P
Plug
-
-
P
25
BOILER FEED WATER
Liquid
958
0.00
27.00
-
-
0.00
128.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
6"
BFW
011
071311
101CS1P
HEADER
HEADER
-
-
P
25
BOILER FEED WATER
Liquid
958
0.00
27.00
-
-
0.00
128.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
2"
BFW
011
071311
101CS1P
011-PZV-0094-B
Reducer
-
-
P
25
BOILER FEED WATER
Liquid
958
0.00
27.00
-
-
0.00
128.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
Reducer
3"-BFW-011071311-101CS1P-P
-
-
P
25
BOILER FEED WATER
Liquid
958
0.00
27.00
-
-
0.00
128.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
-
P
25
958
0.00
27.00
-
-
0.00
128.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
3"
BFW
011
071311
101CS1P
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071311
101CS1P
3"-BFW-011071311-101CS1P-P
Plug
-
BOILER FEED WATER
Liquid
SA-JER-DS011-TRJR-480202
2"
BFW
011
071311
101CS1P
2"-BFW-011071310-103CS1P-H
3"-BFW-011071311-101CS1P-P
-
-
P
25
BOILER FEED WATER
Liquid
958
0.00
27.00
-
-
0.00
128.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
MAX.TEMPERATURE FOR CLOSED OUTLET: 150ºC.
SA-JER-DS011-TRJR-480202
6"
BFW
011
071312
106CS1P
IP-1324 L
Reducer
-
-
H
50
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071312
106CS1P
6"-BFW-011071312-106CS1P-H
Blind flange
-
-
H
25
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
1/2"
BFW
011
071312
106CS1P
011-FE-0094
011-FT-0094
-
-
H
25
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
2"
BFW
011
071312
106CS1P
Reducer
2"-BFW-011071301-101CS1P-H
-
-
H
40
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
6"-BFW-011071312-106CS1P-H
Reducer
-
-
H
50
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
H
25
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
-
H
25
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
6"
BFW
011
071312
106CS1P
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071312
106CS1P
6"-BFW-011071312-106CS1P-H
011-PT-0377
-
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071312
106CS1P
6"-BFW-011071312-106CS1P-H
011-PI-0270
-
-
SA-JER-DS011-TRJR-480202
2"
BFW
011
071312
106CS1P
6"-BFW-011071312-106CS1P-H
Flange
-
-
H
40
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071312
106CS1P
6"-BFW-011071312-106CS1P-H
Blind flange
-
-
H
25
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
1/2"
BFW
011
071312
106CS1P
011-FT-0094
011-FE-0094
-
-
H
25
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
3"
BFW
011
071312
106CS1P
Reducer
Reducer
-
-
H
40
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
6"
BFW
011
071312
106CS1P
Reducer
6"-BFW-011071301-101CS1P-H
-
-
H
50
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071312
106CS1P
6"-BFW-011071312-106CS1P-H
Blind flange
-
-
H
25
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
2"
BFW
011
071313
106CS1P
6"-BFW-011071312-106CS1P-H
Reducer
-
-
H
40
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071313
106CS1P
2"-BFW-011071313-106CS1P-H
Blind flange
-
-
H
25
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
1/2"
BFW
011
071313
106CS1P
011-FE-0198
011-FT-0196
-
-
H
25
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
2"
BFW
011
071313
106CS1P
2"-BFW-011071313-106CS1P-H
Reducer
-
-
H
40
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
1/2"
BFW
011
071313
106CS1P
011-FE-0198
011-FT-0196
-
-
H
25
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
1/2"
BFW
011
071313
106CS1P
Reducer
1/2"-BFW-011071306-101CS1P-H
-
-
H
25
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
1-1/2"
BFW
011
071313
106CS1P
Reducer
Reducer
-
-
H
25
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
2"
BFW
011
071313
106CS1P
Reducer
2"-BFW-011071306-101CS1P-H
-
-
H
40
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
3/4"
BFW
011
071313
106CS1P
2"-BFW-011071313-106CS1P-H
Blind flange
-
-
H
25
BOILER FEED WATER
Liquid
958
60.00
105.00
-
-
90.00
150.00
-
H
135.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
3/4"
BFW
011
200301
101CS1P
SAMPLE COOLER
Reducer
-
-
N
-
BOILER FEED WATER
Liquid
983
12.00
60.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
4"
BFW
011
200301
101CS1P
Reducer
-
-
N
-
BOILER FEED WATER
Liquid
983
12.00
60.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
3/4"
BFW
011
200301
101CS1P
Reducer
SO
-
-
N
-
BOILER FEED WATER
Liquid
983
12.00
60.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
3/4"
BFW
011
200302
101CS1P
3/4"-BFW-011200301-101CS1PN
Reducer
-
-
N
-
BOILER FEED WATER
Liquid
983
12.00
60.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
2"
BFW
011
200302
101CS1P
Reducer
2"-CLD-011200321-101CH2S-P
-
-
N
-
BOILER FEED WATER
Liquid
983
12.00
60.00
-
-
15.00
150.00
-
H
22.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480010
6"
BRN
011
005002
106CS1P
6"-BRN-011007002-106CS2P-H
18"-CRU-011005002-106CS1P-H
-
-
H
50
BRINE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
6"
BRN
011
006001
103CS4P
011-D-0001
SA-JER-DS011-TRJR-480010
-
-
P
25
BRINE
Liquid
917
13.50
148.00
-
-
16.50
178.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
6"
BRN
011
006001
103CS4P
011-D-0001
6"-BRN-011006001-103CS4P-P
-
-
P
25
BRINE
Liquid
917
13.50
148.00
-
-
16.50
178.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
6"
BRN
011
006001
103CS4P
SA-JER-DS011-TRJR-480011
Reducer
-
-
P
25
BRINE
Liquid
917
13.50
148.00
-
-
16.50
178.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
4"
BRN
011
006001
103CS4P
Reducer
4"-BRN-011006001-103CS4P-P
-
-
P
25
BRINE
Liquid
917
13.50
148.00
-
-
16.50
178.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
1"
BRN
011
006001
103CS4P
6"-BRN-011006001-103CS4P-P
Blind flange
-
-
P
25
BRINE
Liquid
917
13.50
148.00
-
-
16.50
178.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
6"
BRN
011
006001
103CS4P
6"-BRN-011006001-103CS4P-P
Reducer
-
-
P
25
BRINE
Liquid
917
13.50
148.00
-
-
16.50
178.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
2"
BRN
011
006001
103CS4P
6"-BRN-011006001-103CS4P-P
011-TT-0182
-
-
P
25
BRINE
Liquid
917
12.00
148.00
-
-
16.50
178.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
4"
BRN
011
006001
103CS4P
Reducer
Reducer
-
-
P
25
BRINE
Liquid
917
13.50
148.00
-
-
16.50
178.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
6"
BRN
011
006001
103CS4P
Reducer
6"-BRN-011006001-103CS4P-P
-
-
P
25
BRINE
Liquid
917
13.50
148.00
-
-
16.50
178.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
1"
BRN
011
006001
103CS4P
6"-BRN-011006001-103CS4P-P
Blind flange
-
-
P
25
BRINE
Liquid
917
13.50
148.00
-
-
16.50
178.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
6"
BRN
011
006001
103CS4P
6"-BRN-011006001-103CS4P-P
SA-JER-DS011-TRJR-480107
-
-
P
25
BRINE
Liquid
917
12.00
148.00
-
-
16.50
178.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
4"
BRN
011
006001
103CS4P
4"-BRN-011006001-103CS4P-P
Reducer
-
-
P
25
BRINE
Liquid
917
12.00
148.00
-
-
16.50
178.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
6"
BRN
011
006001
103CS4P
Reducer
6"-BRN-011006001-103CS4P-P
-
-
P
25
BRINE
Liquid
917
12.00
148.00
-
-
16.50
178.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
6"
BRN
011
006001
103CS4P
6"-BRN-011007002-106CS2P-H
6"-BRN-011006001-103CS4P-P
-
-
P
25
BRINE
Liquid
917
12.00
148.00
-
-
16.50
178.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
6"
BRN
011
006001
103CS4P
SA-JER-DS011-TRJR-480010
011-E-0032-A
-
-
P
25
BRINE
Liquid
917
12.00
148.00
-
-
16.50
178.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
1"
BRN
011
006004
103CS4P
6"-BRN-011006001-103CS4P-P
011-SC-0017
-
-
P
25
BRINE
Liquid
917
13.50
148.00
-
-
16.50
178.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
1"
BRN
011
006004
103CS4P
6"-BRN-011006001-103CS4P-P
Reducer
-
-
P
25
BRINE
Liquid
917
13.50
148.00
-
-
16.50
178.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
BRN
011
006004
103CS4P
Reducer
SAMPLE COOLER
-
-
P
25
BRINE
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480011
3"
BRN
011
006301
103CS4P
3"-LPS-011006301-101CS1P-H
011-D-0001
-
-
H
40
BRINE
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6. ALTERNATIVE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480011
1"
BRN
011
006301
103CS4P
3"-BRN-011006301-103CS4P-H
Blind flange
-
-
H
25
BRINE
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6. ALTERNATIVE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480011
2"
BRN
011
006301
103CS4P
UC
3"-BRN-011006301-103CS4P-H
-
-
H
40
BRINE
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6. ALTERNATIVE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480011
3"
BRN
011
006302
103CS4P
3"-LPS-011006304-101CS1P-H
011-D-0001
-
-
H
40
BRINE
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6. ALTERNATIVE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480011
1"
BRN
011
006302
103CS4P
3"-BRN-011006302-103CS4P-H
Blind flange
-
-
H
25
BRINE
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6. ALTERNATIVE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480011
2"
BRN
011
006302
103CS4P
UC
3"-BRN-011006302-103CS4P-H
-
-
H
40
BRINE
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6. ALTERNATIVE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480012
8"
BRN
011
007001
106CS2P
011-ZV-0111
SA-JER-DS011-TRJR-480013
-
-
H
50
BRINE
Liquid
922
12.00
145.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
8"
BRN
011
007001
106CS2P
SA-JER-DS011-TRJR-480012
8"-BRN-011007001-106CS2P-H
-
-
H
50
BRINE
Liquid
922
12.00
145.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
8"-BRN-011007001-106CS2P-H
Reducer
-
-
H
50
BRINE
Liquid
922
12.00
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
-
H
25
922
12.00
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
Reducer
SA-JER-DS011-TRJR-480013
8"
BRN
011
007001
106CS2P
SA-JER-DS011-TRJR-480013
3/4"
BRN
011
007001
106CS2P
8"-BRN-011007001-106CS2P-H
UC
-
BRINE
Liquid
SA-JER-DS011-TRJR-480013
6"
BRN
011
007001
106CS2P
Reducer
011-G-0024-A
-
-
H
50
BRINE
Liquid
922
12.00
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3"
BRN
011
007002
106CS2P
011-G-0024-A
Reducer
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
6"
BRN
011
007002
106CS2P
Reducer
Reducer
-
-
H
50
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
1/2"
BRN
011
007002
106CS2P
011-FE-0142
011-FT-0142-A
-
-
H
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
6"
BRN
011
007002
106CS2P
6"-BRN-011007002-106CS2P-H
Reducer
-
-
H
50
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
1/2"
BRN
011
007002
106CS2P
011-FE-0142
011-FT-0142-B
-
-
H
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
1/2"
BRN
011
007002
106CS2P
011-FE-0142
011-FT-0142-A
-
-
H
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3/4"
BRN
011
007002
106CS2P
6"-BRN-011007002-106CS2P-H
Blind flange
-
-
H
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3"
BRN
011
007002
106CS2P
Reducer
3"-BRN-011007002-106CS2P-H
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
1/2"
BRN
011
007002
106CS2P
011-FE-0142
011-FT-0142-B
-
-
H
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3/4"
BRN
011
007002
106CS2P
6"-BRN-011007002-106CS2P-H
011-PI-0303
-
-
H
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
6"
BRN
011
007002
106CS2P
SA-JER-DS011-TRJR-480013
6"-BRN-011005002-106CS1P-H
-
-
H
50
BRINE
Liquid
922
15.30
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
3/4"
BRN
011
007002
106CS2P
6"-BRN-011007002-106CS2P-H
Blind flange
-
-
H
25
BRINE
Liquid
922
15.30
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
6"
BRN
011
007002
106CS2P
6"-BRN-011007002-106CS2P-H
6"-BRN-011006001-103CS4P-P
-
-
H
50
BRINE
Liquid
922
15.30
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3"
BRN
011
007002
106CS2P
Reducer
Reducer
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480250
3/4"
BRN
011
007002
106CS2P
SA-JER-DS011-TRJR-480013
2"-OLW-011171347-101CS1P-N
-
-
P
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
6"
BRN
011
007002
106CS2P
Reducer
6"-BRN-011007002-106CS2P-H
-
-
H
50
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3/4"
BRN
011
007002
106CS2P
6"-BRN-011007002-106CS2P-H
Blind flange
-
-
H
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
6"
BRN
011
007002
106CS2P
6"-BRN-011007002-106CS2P-H
SA-JER-DS011-TRJR-480010
-
-
H
50
BRINE
Liquid
922
15.30
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3"
BRN
011
007002
106CS2P
3"-BRN-011007002-106CS2P-H
Reducer
-
-
H
40
BRINE
Liquid
922
15.30
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
6"
BRN
011
007002
106CS2P
Reducer
6"-BRN-011007002-106CS2P-H
-
-
H
50
BRINE
Liquid
922
15.30
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
8"
BRN
011
007004
106CS2P
8"-BRN-011007001-106CS2P-H
8"-BRN-011007004-106CS2P-H
-
-
H
50
BRINE
Liquid
922
12.00
145.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
8"
BRN
011
007004
106CS2P
8"-BRN-011007004-106CS2P-H
Reducer
-
-
H
50
BRINE
Liquid
922
12.00
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3/4"
BRN
011
007004
106CS2P
8"-BRN-011007004-106CS2P-H
011-PI-0296
-
-
H
25
BRINE
Liquid
922
12.00
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3/4"
BRN
011
007004
106CS2P
8"-BRN-011007004-106CS2P-H
UC
-
-
H
25
BRINE
Liquid
922
12.00
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 13 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480013
6"
BRN
011
007004
106CS2P
Reducer
011-G-0024-B
-
-
H
50
BRINE
Liquid
922
12.00
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3"
BRN
011
007005
106CS2P
011-G-0024-B
Reducer
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
6"
BRN
011
007005
106CS2P
Reducer
6"-BRN-011007005-106CS2P-H
-
-
H
50
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3/4"
BRN
011
007005
106CS2P
6"-BRN-011007005-106CS2P-H
011-PI-0302
-
-
H
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480250
3/4"
BRN
011
007005
106CS2P
SA-JER-DS011-TRJR-480013
2"-OLW-011171348-101CS1P-N
-
-
P
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480013
6"
BRN
011
007005
106CS2P
6"-BRN-011007005-106CS2P-H
6"-BRN-011007002-106CS2P-H
-
-
H
50
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480013
1-1/2"
BRN
011
007006
106CS2P
6"-BRN-011007002-106CS2P-H
Insul Brk
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
1-1/2"
BRN
011
007006
106CS2P
Insul Brk
Reducer
-
-
P
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
-
-
P
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
2"-CLD-011007304-101CH2S-P
-
-
P
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
Insul Brk
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
-
-
P
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
-
-
P
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
1-1/2"-BRN-011007006-106CS2P- 3/4"-OLW-011007303-101CS1PP N
SA-JER-DS011-TRJR-480013
3/4"
BRN
011
007006
106CS2P
SA-JER-DS011-TRJR-480013
2"
BRN
011
007006
106CS2P
Reducer
SA-JER-DS011-TRJR-480013
1-1/2"
BRN
011
007006
106CS2P
8"-BRN-011007001-106CS2P-H
1-1/2"-BRN-011007006-106CS2PP 1-1/2"-BRN-011007006-106CS2PP
SA-JER-DS011-TRJR-480013
1-1/2"
BRN
011
007006
106CS2P
Insul Brk
SA-JER-DS011-TRJR-480013
3/4"
BRN
011
007006
106CS2P
011-G-0024-A
SA-JER-DS011-TRJR-480013
1-1/2"
BRN
011
007007
106CS2P
6"-BRN-011007005-106CS2P-H
Insul Brk
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
1-1/2"
BRN
011
007007
106CS2P
Insul Brk
Reducer
-
-
P
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3/4"
BRN
011
007007
106CS2P
-
-
P
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
2"
BRN
011
007007
106CS2P
Reducer
2"-CLD-011007303-101CH2S-P
-
-
P
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
1-1/2"
BRN
011
007007
106CS2P
8"-BRN-011007004-106CS2P-H
Insul Brk
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
1-1/2"
BRN
011
007007
106CS2P
Insul Brk
-
-
P
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3/4"
BRN
011
007007
106CS2P
011-G-0024-B
-
-
P
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
6"
BRN
011
007008
106CS2P
6"-BRN-011007008-106CS2P-H
6"-BRN-011007002-106CS2P-H
-
-
H
50
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
1-1/2"-BRN-011007007-106CS2P- 3/4"-OLW-011007304-101CS1PP N
1-1/2"-BRN-011007007-106CS2PP 1-1/2"-BRN-011007007-106CS2PP
SA-JER-DS011-TRJR-480013
6"
BRN
011
007008
106CS2P
8"-BRN-011007001-106CS2P-H
6"-BRN-011007008-106CS2P-H
-
-
H
50
BRINE
Liquid
922
12.00
145.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3/4"
BRN
011
007008
106CS2P
6"-BRN-011007008-106CS2P-H
Blind flange
-
-
H
25
BRINE
Liquid
922
12.00
145.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3/4"
BRN
011
007009
106CS2P
6"-BRN-011007002-106CS2P-H
011-SC-0018
-
-
H
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
BRN
011
007009
106CS2P
6"-BRN-011007002-106CS2P-H
SAMPLE COOLER
-
-
H
25
BRINE
Liquid
922
17.50
145.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
M or Q
N
N
N
N
N
N
-
THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE.NOTE 6.
SA-JER-DS011-TRJR-480013
2"
BRN
011
007011
106CS2P
6"-BRN-011007002-106CS2P-H
2"-BRN-011007011-106CS2P-H
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
1/2"
BRN
011
007011
106CS2P
011-FE-0177
011-FT-0177
-
-
H
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
1/2"
BRN
011
007011
106CS2P
011-FE-0177
011-FT-0177
-
-
H
25
BRINE
Liquid
922
17.50
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
2"
BRN
011
007011
106CS2P
2"-BRN-011007011-106CS2P-H
SA-JER-DS011-TRJR-480011
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
2"
BRN
011
007011
106CS2P
SA-JER-DS011-TRJR-480013
011-D-0001
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
2"
BRN
011
007011
106CS2P
2"-BRN-011007011-106CS2P-H
011-D-0001
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
2"
BRN
011
007011
106CS2P
2"-BRN-011007011-106CS2P-H
011-D-0001
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
2"
BRN
011
007011
106CS2P
2"-BRN-011007011-106CS2P-H
011-D-0001
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
2"
BRN
011
007011
106CS2P
2"-BRN-011007011-106CS2P-H
011-D-0001
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
2"
BRN
011
007011
106CS2P
2"-BRN-011007011-106CS2P-H
011-D-0001
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
2"
BRN
011
007012
106CS2P
2"-BRN-011007011-106CS2P-H
SA-JER-DS011-TRJR-480012
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
2"
BRN
011
007012
106CS2P
SA-JER-DS011-TRJR-480013
011-D-0002
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
2"
BRN
011
007012
106CS2P
2"-BRN-011007012-106CS2P-H
011-D-0002
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
2"
BRN
011
007012
106CS2P
2"-BRN-011007012-106CS2P-H
011-D-0002
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
2"
BRN
011
007012
106CS2P
2"-BRN-011007012-106CS2P-H
011-D-0002
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
2"
BRN
011
007012
106CS2P
2"-BRN-011007012-106CS2P-H
011-D-0002
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
2"
BRN
011
007012
106CS2P
2"-BRN-011007012-106CS2P-H
011-D-0002
-
-
H
40
BRINE
Liquid
922
17.50
145.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
6"
BRN
011
007013
103CS4P
011-D-0002
Reducer
-
-
P
25
BRINE
Liquid
922
12.00
145.00
-
-
16.50
178.00
-
H
24.75
ASME N/A
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
8"
BRN
011
007013
103CS4P
Reducer
011-ZV-0111
-
-
P
25
BRINE
Liquid
922
12.00
145.00
-
-
16.50
178.00
-
H
24.75
ASME N/A
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
6"
BRN
011
007013
103CS4P
011-D-0002
8"-BRN-011007013-103CS4P-P
-
-
P
25
BRINE
Liquid
922
12.00
145.00
-
-
16.50
178.00
-
H
24.75
ASME N/A
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
3"
BRN
011
007301
103CS4P
3"-LPS-011007301-101CS1P-H
011-D-0002
-
-
H
40
BRINE
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6. ALTERNATIVE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480012
1"
BRN
011
007301
103CS4P
3"-BRN-011007301-103CS4P-H
Blind flange
-
-
H
25
BRINE
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6. ALTERNATIVE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480012
2"
BRN
011
007301
103CS4P
UC
3"-BRN-011007301-103CS4P-H
-
-
H
40
BRINE
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6. ALTERNATIVE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480012
3"
BRN
011
007302
103CS4P
3"-LPS-011007303-101CS1P-H
011-D-0002
-
-
H
40
BRINE
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6. ALTERNATIVE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480012
2"
BRN
011
007302
103CS4P
UC
3"-BRN-011007302-103CS4P-H
-
-
H
40
BRINE
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6. ALTERNATIVE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480012
1"
BRN
011
007302
103CS4P
3"-BRN-011007302-103CS4P-H
Blind flange
-
-
H
25
BRINE
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6. ALTERNATIVE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480107
6"
BRN
011
042001
103CS4P
011-E-0032-B
SA-JER-DS011-TRJR-480108
-
-
P
25
BRINE
Liquid
969
11.00
85.00
-
-
16.50
180.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480108
6"
BRN
011
042001
103CS4P
SA-JER-DS011-TRJR-480107
Reducer
-
-
P
25
BRINE
Liquid
969
11.00
85.00
-
-
16.50
180.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480108
1"
BRN
011
042001
103CS4P
6"-BRN-011042001-103CS4P-P
UC
-
-
P
25
BRINE
Liquid
969
11.00
85.00
-
-
16.50
180.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480108
6"
BRN
011
042001
103CS4P
6"-BRN-011042001-103CS4P-P
Reducer
-
-
P
25
BRINE
Liquid
969
11.00
85.00
-
-
16.50
180.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
2"
BRN
011
042001
103CS4P
6"-BRN-011042001-103CS4P-P
011-TT-0183
-
-
P
25
BRINE
Liquid
969
11.00
85.00
-
-
16.50
180.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480108
4"
BRN
011
042001
103CS4P
Reducer
011-A-0006-A/B
-
-
P
25
BRINE
Liquid
969
11.00
85.00
-
-
16.50
180.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480108
4"
BRN
011
042001
103CS4P
Reducer
011-A-0006-A/B
-
-
P
25
BRINE
Liquid
969
11.00
85.00
-
-
16.50
180.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480108
4"
BRN
011
042002
101CS4P
011-A-0006-A/B
Reducer
-
-
P
25
BRINE
Liquid
981
9.00
65.00
-
-
16.50
115.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480108
4"
BRN
011
042002
101CS4P
011-A-0006-A/B
Reducer
-
-
P
25
BRINE
Liquid
981
9.00
65.00
-
-
16.50
115.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480108
6"
BRN
011
042002
101CS4P
Reducer
SA-JER-DS011-TRJR-480109
-
-
P
25
BRINE
Liquid
981
9.00
65.00
-
-
16.50
115.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480108
6"
BRN
011
042002
101CS4P
Reducer
6"-BRN-011042002-101CS4P-P
-
-
P
25
BRINE
Liquid
981
9.00
65.00
-
-
16.50
115.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480108
2"
BRN
011
042002
101CS4P
6"-BRN-011042002-101CS4P-P
011-TT-0186
-
-
P
25
BRINE
Liquid
981
9.00
65.00
-
-
16.50
115.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480109
6"
BRN
011
042002
101CS4P
SA-JER-DS011-TRJR-480108
011-E-0033
-
-
P
25
BRINE
Liquid
981
9.00
65.00
-
-
16.50
115.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480109
6"
BRN
011
042003
101CS4P
011-E-0033
SA-JER-DS011-TRJR-480132
-
-
N
-
BRINE
Liquid
991
9.20
41.50
-
-
16.50
95.00
-
H
24.75
NFS
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
6"
BRN
011
042003
101CS4P
SA-JER-DS011-TRJR-480109
6"-BRN-011042003-101CS4P-N
-
-
N
-
BRINE
Liquid
991
9.20
41.50
-
-
16.50
95.00
-
H
24.75
NFS
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
6"
BRN
011
042003
101CS4P
6"-BRN-011042003-101CS4P-N
IP-1311-L
-
-
N
-
BRINE
Liquid
991
9.20
41.50
-
-
16.00
80.00
-
H
24.00
NFS
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480109
1"
BRN
011
042004
101CS4P
6"-BRN-011042003-101CS4P-N
011-SC-0005
-
-
N
-
BRINE
Liquid
991
9.20
41.50
-
-
16.00
95.00
-
H
24.00
NFS
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
1/2"
BRN
011
042004
101CS4P
Reducer
SO
-
-
N
-
BRINE
Liquid
991
9.20
41.50
-
-
16.00
95.00
-
-
-
NFS
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480109
1-1/2"
BRN
011
042006
101CS4P
6"-BRN-011042003-101CS4P-N
Reducer
-
-
N
-
BRINE
Liquid
981
9.20
41.50
-
-
16.50
95.00
-
H
24.75
NFS
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480109
2"
BRN
011
042006
101CS4P
Reducer
2"-CLD-011042301-101CH2S-P
-
-
N
-
BRINE
Liquid
981
9.20
41.50
-
-
16.50
95.00
-
H
24.75
NFS
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
1"
BRN
011
042007
103CS4P
6"-BRN-011042001-103CS4P-P
Reducer
-
-
P
25
BRINE
Liquid
969
11.00
85.00
-
-
16.50
180.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
1"
BRN
011
042007
103CS4P
1"-BRN-011042007-103CS4P-P
Blind flange
-
-
P
25
BRINE
Liquid
969
11.00
85.00
-
-
16.50
180.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
2"
BRN
011
042007
103CS4P
Reducer
2"-CLD-011042302-101CH2S-P
-
-
P
25
BRINE
Liquid
969
11.00
85.00
-
-
16.50
180.00
-
H
24.75
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480108
1-1/2"
BRN
011
042008
101CS4P
011-A-0006-A/B
Reducer
-
-
P
25
BRINE
Liquid
981
9.00
65.00
-
-
16.00
115.00
-
H
24.00
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
-
-
P
25
BRINE
Liquid
981
9.00
65.00
-
-
16.00
115.00
-
H
24.00
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480108
1-1/2"
BRN
011
042008
101CS4P
011-A-0006-A/B
1-1/2"-BRN-011042008-101CS4PP
SA-JER-DS011-TRJR-480108
2"
BRN
011
042008
101CS4P
Reducer
2"-CLD-011042303-101CH2S-N
-
-
P
25
BRINE
Liquid
981
9.00
65.00
-
-
16.00
115.00
-
H
24.00
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480108
1"
BRN
011
042008
101CS4P
1-1/2"-BRN-011042008-101CS4P1"-OLW-011042302-101CS1P-N P
-
-
P
25
BRINE
Liquid
981
9.00
65.00
-
-
16.00
115.00
-
H
24.00
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
N
N
N
N
N
N
-
NOTE 6
N
N
N
N
N
N
-
NOTE 6
if insulated M or N or Q SA-JER-DS011-TRJR-480107
-
BRN
011
042601
103CS4P
011-E-0032-A/B
TRIM
-
-
H
-
-
-
-
12.00
150.00
-
-
38.30
180.00
-
Visual Test
0.00
NFS
By Code if NOT insulated B or if insulated M or N or Q
SA-JER-DS011-TRJR-480107
2"
BRN
011
042601
103CS4P
011-E-0032-A
011-TW-0334
-
-
H
40
-
-
-
12.00
150.00
-
-
38.30
180.00
-
H
57.45
NFS
By Code if NOT insulated B or
SA-JER-DS011-TRJR-480274
3/4"
BRN
011
200001
103CS4P
SAMPLE COOLER
Reducer
-
-
N
-
BRINE
Liquid
983
13.50
60.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
4"
BRN
011
200001
103CS4P
Reducer
Reducer
-
-
N
-
BRINE
Liquid
983
13.50
60.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
1"
BRN
011
200001
103CS4P
Reducer
SO
-
-
N
-
BRINE
Liquid
983
13.50
60.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
BRN
011
200002
106CS2P
SAMPLE COOLER
Reducer
-
-
N
-
BRINE
Liquid
983
17.50
60.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 14 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
TO
Reducer
TYPE
TEMP. (ºC)
INSULATION (NOTE 2)
TYPE
FLUID
THICKNESS (mm)
PHASE
(NOTE 3)
DOC. No.
DENSITY (kg/m3)
(NOTE 4)
OPERATING CONDITIONS PRESS. (BARG)
TEMP. (ºC)
DESIGN CONDITIONS
ALTERNATE CONDITIONS PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
(ºC)
TEST CONDITIONS
MEDIUM (NOTE 5)
PRESS. (BARG)
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6)
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480274
4"
BRN
011
200002
106CS2P
Reducer
-
-
N
-
BRINE
Liquid
983
17.50
60.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
BRN
011
200002
106CS2P
Reducer
SO
-
-
N
-
BRINE
Liquid
983
17.50
60.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
1"
BRN
011
200003
103CS4P
1"-BRN-011200001-103CS4P-N
Reducer
-
-
N
-
BRINE
Liquid
983
13.50
60.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
2"
BRN
011
200003
103CS4P
Reducer
2"-CLD-011200315-101CH2S-N
-
-
N
-
BRINE
Liquid
983
13.50
60.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
BRN
011
200004
106CS2P 3/4"-BRN-011200002-106CS2P-N
Reducer
-
-
N
-
BRINE
Liquid
983
17.50
60.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
2"
BRN
011
200004
106CS2P
Reducer
2"-CLD-011200316-101CH2S-N
-
-
N
-
BRINE
Liquid
983
17.50
60.00
-
-
21.12
178.00
-
H
31.68
NFS
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480125
1"
CHP
011
053001
103SC1P
1"-CHP-011053406-106SC1P-N
Reducer
-
-
N
-
DEMULSIFIER
Liquid
950
3.50
47.00
-
-
19.20
56.30
80.00
80.00
-
H
28.80
NFS
NO
E
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480125
2"
CHP
011
053001
103SC1P
Reducer
SA-JER-DS011-TRJR-480001
-
-
N
-
DEMULSIFIER
Liquid
950
3.50
47.00
-
-
19.20
56.30
80.00
80.00
-
H
28.80
NFS
NO
E
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480001
2"
CHP
011
053001
103SC1P
SA-JER-DS011-TRJR-480125
Reducer
-
-
N
-
DEMULSIFIER
Liquid
977
3.50
47.00
-
-
19.20
56.30
80.00
80.00
-
H
28.80
NFS
NO
E
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480001
1"
CHP
011
053001
103SC1P
Reducer
1"-CHP-011053001-103SC1P-N
-
-
N
-
DEMULSIFIER
Liquid
977
3.50
47.00
-
-
19.20
56.30
80.00
80.00
-
H
28.80
NFS
NO
E
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480001
1"
CHP
011
053001
103SC1P
1"-CHP-011053001-103SC1P-N
18"-CRU-011098001-103CS1P-N
-
-
N
-
DEMULSIFIER
Liquid
977
3.50
47.00
-
-
16.50
56.30
80.00
80.00
-
H
24.75
NFS
NO
E
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480125
1"
CHP
011
053002
106SC1P
1"-CHP-011053003-106SC1P-N
SA-JER-DS011-TRJR-480010
-
-
N
-
DEMULSIFIER
Liquid
950
18.00
47.00
-
-
56.30
80.00
-
H
84.45
NFS
NO
E
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480010
1"
CHP
011
053002
106SC1P
SA-JER-DS011-TRJR-480125
Insul Brk
-
-
N
-
DEMULSIFIER
Liquid
977
18.00
47.00
-
-
56.30
80.00
-
H
84.45
NFS
NO
E
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480010
1"
CHP
011
053002
106SC1P
Insul Brk
18"-CRU-011005002-106CS1P-H
-
-
H
25
DEMULSIFIER
Liquid
977
18.00
47.00
-
-
56.30
80.00
-
H
84.45
NFS
NO
E
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480125
1"
CHP
011
053003
106SC1P
1"-CHP-011053407-106SC1P-N
SA-JER-DS011-TRJR-480013
-
-
N
-
DEMULSIFIER
Liquid
950
18.00
47.00
-
-
56.30
80.00
-
H
84.45
NFS
NO
E
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480013
1"
CHP
011
053003
106SC1P
SA-JER-DS011-TRJR-480125
Insul Brk
-
-
N
-
DEMULSIFIER
Liquid
977
18.00
47.00
-
-
56.30
80.00
-
H
84.45
NFS
NO
E
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
1"
CHP
011
053003
106SC1P
Insul Brk
18"-CRU-011006002-106CS2P-H
-
-
H
25
DEMULSIFIER
Liquid
977
18.00
47.00
-
-
56.30
80.00
-
H
84.45
NFS
NO
E
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480125
1/2"
CHP
011
053401
101SC1P 1/2"-CHP-011053402-101SC1P-N
011-G-0030-A
-
-
N
-
DEMULSIFIER
Liquid
950
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1/2"
CHP
011
053401
101SC1P 1/2"-CHP-011053401-101SC1P-N
011-G-0030-B
-
-
N
-
DEMULSIFIER
Liquid
950
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
2"
CHP
011
053401
101SC1P
011-D-0031
Reducer
-
-
N
-
DEMULSIFIER
Liquid
950
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1/2"
CHP
011
053401
101SC1P
Reducer
1/2"-CHP-011053401-101SC1P-N
-
-
N
-
DEMULSIFIER
Liquid
950
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1/2"
CHP
011
053401
101SC1P 1/2"-CHP-011053401-101SC1P-N 1/2"-CHP-011053411-101SC1P-N
-
-
N
-
DEMULSIFIER
Liquid
950
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
2"
CHP
011
053402
101SC1P
011-D-0031
Reducer
-
-
N
-
DEMULSIFIER
Liquid
950
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1/2"
CHP
011
053402
101SC1P
Reducer
1/2"-CHP-011053401-101SC1P-N
-
-
N
-
DEMULSIFIER
Liquid
950
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
2"
CHP
011
053403
101SC1P
011-D-0031
2"-CHP-011053403-101SC1P-N
-
-
N
-
DEMULSIFIER
Liquid
950
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
2"
CHP
011
053403
101SC1P
011-D-0031
2"-CHP-011053403-101SC1P-N
-
-
N
-
DEMULSIFIER
Liquid
950
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
2"
CHP
011
053403
101SC1P
2"-CHP-011053403-101SC1P-N
DRIP PAN
-
-
N
-
DEMULSIFIER
Liquid
950
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
NO
E
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480125
2"
CHP
011
053404
101SC1P
Blind flange
011-D-0031
-
-
N
-
DEMULSIFIER
Liquid
950
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1/2"
CHP
011
053406
106SC1P
011-G-0030-A
Reducer
-
-
N
-
DEMULSIFIER
Liquid
950
3.50
47.00
-
-
19.20
80.00
-
H
28.80
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1"
CHP
011
053406
106SC1P
Reducer
1"-CHP-011053001-103SC1P-N
-
-
N
-
DEMULSIFIER
Liquid
950
3.50
47.00
-
-
19.20
80.00
-
H
28.80
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1/2"
CHP
011
053406
106SC1P
011-G-0030-B
1/2"-CHP-011053406-106SC1P-N
-
-
N
-
DEMULSIFIER
Liquid
950
3.50
47.00
-
-
19.20
80.00
-
H
28.80
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1/2"
CHP
011
053406
106SC1P 1/2"-CHP-011053406-106SC1P-N
Reducer
-
-
N
-
DEMULSIFIER
Liquid
950
3.50
47.00
-
-
19.20
80.00
-
H
28.80
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1"
CHP
011
053406
106SC1P
011-PZV-0036
-
-
N
-
DEMULSIFIER
Liquid
950
3.50
47.00
-
-
19.20
80.00
-
H
28.80
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1/2"
CHP
011
053406
106SC1P 1/2"-CHP-011053406-106SC1P-N
Reducer
-
-
N
-
DEMULSIFIER
Liquid
950
3.50
47.00
-
-
19.20
80.00
-
H
28.80
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1"
CHP
011
053406
106SC1P
Reducer
011-PZV-0037
-
-
N
-
DEMULSIFIER
Liquid
950
3.50
47.00
-
-
19.20
80.00
-
H
28.80
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1/2"
CHP
011
053407
106SC1P
011-G-0031-A
Reducer
-
-
N
-
DEMULSIFIER
Liquid
950
18.00
47.00
-
-
56.30
80.00
-
H
84.45
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
Reducer
SA-JER-DS011-TRJR-480125
1"
CHP
011
053407
106SC1P
Reducer
1"-CHP-011053003-106SC1P-N
-
-
N
-
DEMULSIFIER
Liquid
950
18.00
47.00
-
-
56.30
80.00
-
H
84.45
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1/2"
CHP
011
053407
106SC1P
011-G-0031-B
1/2"-CHP-011053407-106SC1P-N
-
-
N
-
DEMULSIFIER
Liquid
950
18.00
47.00
-
-
56.30
80.00
-
H
84.45
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1/2"
CHP
011
053407
106SC1P 1/2"-CHP-011053407-106SC1P-N
Reducer
-
-
N
-
DEMULSIFIER
Liquid
950
18.00
47.00
-
-
56.30
80.00
-
H
84.45
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1"
CHP
011
053407
106SC1P
011-PZV-0065
-
-
N
-
DEMULSIFIER
Liquid
950
18.00
47.00
-
-
56.30
80.00
-
H
84.45
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1/2"
CHP
011
053407
106SC1P 1/2"-CHP-011053407-106SC1P-N
Reducer
-
-
N
-
DEMULSIFIER
Liquid
950
18.00
47.00
-
-
56.30
80.00
-
H
84.45
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1"
CHP
011
053407
106SC1P
Reducer
011-PZV-0076
-
-
N
-
DEMULSIFIER
Liquid
950
18.00
47.00
-
-
56.30
80.00
-
H
84.45
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1"
CHP
011
053408
101SC1P
011-PZV-0065
1"-CHP-011053410-101SC1P-N
-
-
N
-
DEMULSIFIER
Liquid
950
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1"
CHP
011
053409
101SC1P
011-PZV-0076
1"-CHP-011053410-101SC1P-N
-
-
N
-
DEMULSIFIER
Liquid
950
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1"
CHP
011
053410
101SC1P
011-PZV-0036
Reducer
-
-
N
-
DEMULSIFIER
Liquid
950
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
2"
CHP
011
053410
101SC1P
Reducer
011-D-0031
-
-
N
-
DEMULSIFIER
Liquid
950
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1"
CHP
011
053410
101SC1P
011-PZV-0037
1"-CHP-011053410-101SC1P-N
-
-
N
-
DEMULSIFIER
Liquid
950
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1/2"
CHP
011
053411
101SC1P 1/2"-CHP-011053401-101SC1P-N
011-G-0031-A
-
-
N
-
DEMULSIFIER
Liquid
950
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1/2"
CHP
011
053411
101SC1P 1/2"-CHP-011053411-101SC1P-N
011-G-0031-B
-
-
N
-
DEMULSIFIER
Liquid
950
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480125
1/2"
CHP
011
053411
101SC1P 1/2"-CHP-011053411-101SC1P-N 1/2"-CHP-011053401-101SC1P-N
-
-
N
-
DEMULSIFIER
Liquid
950
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1"
CHP
011
054001
101SC1P 1/2"-CHP-011054410-101SC1P-N
Reducer
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
7.40
47.00
-
-
10.60
80.00
-
H
15.90
NFS
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480126
2"
CHP
011
054001
101SC1P
Reducer
SA-JER-DS011-TRJR-480020
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
7.40
47.00
-
-
10.60
80.00
-
H
15.90
NFS
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480020
2"
CHP
011
054001
101SC1P
SA-JER-DS011-TRJR-480126
Reducer
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
7.40
47.00
-
-
10.60
80.00
-
H
15.90
NFS
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480020
1"
CHP
011
054001
101SC1P
Reducer
1"-CHP-011054001-101SC1P-N
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
7.40
47.00
-
-
10.60
80.00
-
H
15.90
NFS
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480020
1"
CHP
011
054001
101SC1P
1"-CHP-011054001-101SC1P-N
24"-NAP-011011001-101CH2S-P
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
7.40
47.00
-
-
10.60
80.00
-
H
15.90
NFS
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480126
1"
CHP
011
054002
101SC1P 1/2"-CHP-011054411-101SC1P-N
Reducer
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
8.10
47.00
-
-
12.00
80.00
-
H
18.00
NFS
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480126
2"
CHP
011
054002
101SC1P
Reducer
SA-JER-DS011-TRJR-480043
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
8.10
47.00
-
-
12.00
80.00
-
H
18.00
NFS
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480043
2"
CHP
011
054002
101SC1P
SA-JER-DS011-TRJR-480126
Reducer
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
8.10
47.00
-
-
12.00
80.00
-
H
18.00
NFS
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480043
1"
CHP
011
054002
101SC1P
Reducer
Insul Brk
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
8.10
47.00
-
-
12.00
80.00
-
H
18.00
NFS
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480043
1"
CHP
011
054002
101SC1P
Insul Brk
40"-NAP-011018001-101CH2S-P
-
-
P
25
NEUTRALIZING AGENT
Liquid
1000
8.10
47.00
-
-
12.00
80.00
-
H
18.00
NFS
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480126
1"
CHP
011
054003
101SC1P 1/2"-CHP-011054412-101SC1P-N
Reducer
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
6.20
47.00
-
-
10.90
80.00
-
H
16.35
NFS
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480126
2"
CHP
011
054003
101SC1P
Reducer
SA-JER-DS011-TRJR-480080
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
6.20
47.00
-
-
10.90
80.00
-
H
16.35
NFS
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480080
2"
CHP
011
054003
101SC1P
SA-JER-DS011-TRJR-480126
Reducer
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
6.20
47.00
-
-
10.90
80.00
-
H
16.35
NFS
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480080
1"
CHP
011
054003
101SC1P
Reducer
Insul Brk
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
6.20
47.00
-
-
10.90
80.00
-
H
16.35
NFS
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480080
1"
CHP
011
054003
101SC1P
Insul Brk
60"-PRO-011030002-101CH4S-P
-
-
P
25
NEUTRALIZING AGENT
Liquid
1000
6.20
47.00
-
-
10.90
80.00
-
H
16.35
NFS
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480080
1"
CHP
011
054003
101SC1P
1"-CHP-011054003-101SC1P-N
Insul Brk
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
6.20
47.00
-
-
10.90
80.00
-
H
16.35
NFS
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480080
1"
CHP
011
054003
101SC1P
Insul Brk
60"-PRO-011030001-101CH4S-P
-
-
P
25
NEUTRALIZING AGENT
Liquid
1000
6.20
47.00
-
-
10.90
80.00
-
H
16.35
NFS
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480126
1/2"
CHP
011
054410
101SC1P
011-G-0034-A
1"-CHP-011054001-101SC1P-N
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
7.40
47.00
-
-
10.60
80.00
-
H
15.90
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
3/4"
CHP
011
054410
101SC1P 1/2"-CHP-011054410-101SC1P-N
Reducer
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
7.40
47.00
-
-
10.60
80.00
-
H
15.90
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1"
CHP
011
054410
101SC1P
Reducer
011-PZV-0041
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
7.40
47.00
-
-
10.60
80.00
-
H
15.90
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1/2"
CHP
011
054410
101SC1P
011-G-0034-B
1/2"-CHP-011054410-101SC1P-N
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
7.40
47.00
-
-
10.60
80.00
-
H
15.90
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
3/4"
CHP
011
054410
101SC1P 1/2"-CHP-011054410-101SC1P-N
Reducer
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
7.40
47.00
-
-
10.60
80.00
-
H
15.90
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
Reducer
SA-JER-DS011-TRJR-480126
1"
CHP
011
054410
101SC1P
Reducer
011-PZV-0043
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
7.40
47.00
-
-
10.60
80.00
-
H
15.90
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1/2"
CHP
011
054411
101SC1P
011-G-0033-A
1"-CHP-011054002-101SC1P-N
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
8.10
47.00
-
-
12.00
80.00
-
H
18.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
3/4"
CHP
011
054411
101SC1P 1/2"-CHP-011054411-101SC1P-N
Reducer
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
8.10
47.00
-
-
12.00
80.00
-
H
18.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1"
CHP
011
054411
101SC1P
Reducer
011-PZV-0040
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
8.10
47.00
-
-
12.00
80.00
-
H
18.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1/2"
CHP
011
054411
101SC1P
011-G-0033-B
1/2"-CHP-011054411-101SC1P-N
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
8.10
47.00
-
-
12.00
80.00
-
H
18.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
3/4"
CHP
011
054411
101SC1P 1/2"-CHP-011054411-101SC1P-N
Reducer
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
8.10
47.00
-
-
12.00
80.00
-
H
18.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1"
CHP
011
054411
101SC1P
Reducer
011-PZV-0042
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
8.10
47.00
-
-
12.00
80.00
-
H
18.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1/2"
CHP
011
054412
101SC1P
011-G-0032-A
1"-CHP-011054003-101SC1P-N
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
6.20
47.00
-
-
10.90
80.00
-
H
16.35
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
3/4"
CHP
011
054412
101SC1P 1/2"-CHP-011054412-101SC1P-N
Reducer
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
6.20
47.00
-
-
10.90
80.00
-
H
16.35
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1"
CHP
011
054412
101SC1P
011-PZV-0066
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
6.20
47.00
-
-
10.90
80.00
-
H
16.35
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
3/4"
CHP
011
054412
101SC1P 1/2"-CHP-011054412-101SC1P-N
Reducer
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
6.20
47.00
-
-
10.90
80.00
-
H
16.35
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1"
CHP
011
054412
101SC1P
Reducer
011-PZV-0067
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
6.20
47.00
-
-
10.90
80.00
-
H
16.35
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
2"
CHP
011
054413
101SC1P
011-D-0032
Reducer
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1/2"
CHP
011
054413
101SC1P
Reducer
011-G-0034-B
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1/2"
CHP
011
054413
101SC1P 1/2"-CHP-011054413-101SC1P-N
011-G-0032-B
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1/2"
CHP
011
054413
101SC1P 1/2"-CHP-011054413-101SC1P-N
011-G-0033-B
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1/2"
CHP
011
054413
101SC1P 1/2"-CHP-011054413-101SC1P-N
011-G-0032-A
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1/2"
CHP
011
054413
101SC1P 1/2"-CHP-011054413-101SC1P-N
011-G-0033-A
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1/2"
CHP
011
054413
101SC1P 1/2"-CHP-011054413-101SC1P-N
011-G-0034-A
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-380001
Reducer
Page 15 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
TO
INSULATION (NOTE 2)
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480126
1/2"
CHP
011
054414
101SC1P 1/2"-CHP-011054414-101SC1P-N 1/2"-CHP-011054413-101SC1P-N
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1/2"
CHP
011
054414
101SC1P 1/2"-CHP-011054414-101SC1P-N 1/2"-CHP-011054413-101SC1P-N
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1/2"
CHP
011
054414
101SC1P 1/2"-CHP-011054418-101SC1P-N 1/2"-CHP-011054413-101SC1P-N
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1/2"
CHP
011
054414
101SC1P 1/2"-CHP-011054414-101SC1P-N 1/2"-CHP-011054413-101SC1P-N
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
2"
CHP
011
054416
101SC1P
Blind flange
011-D-0032
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
2"
CHP
011
054417
101SC1P
011-D-0032
2"-CHP-011054417-101SC1P-N
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
2"
CHP
011
054417
101SC1P
011-D-0032
2"-CHP-011054417-101SC1P-N
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
2"
CHP
011
054417
101SC1P
2"-CHP-011054417-101SC1P-N
DRIP PAN
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
2"
CHP
011
054418
101SC1P
011-D-0032
Reducer
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1/2"
CHP
011
054418
101SC1P
Reducer
1/2"-CHP-011054414-101SC1P-N
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1"
CHP
011
054419
101SC1P
011-PZV-0041
Reducer
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
2"
CHP
011
054419
101SC1P
Reducer
011-D-0032
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1"
CHP
011
054420
101SC1P
011-PZV-0067
1"-CHP-011054424-101SC1P-N
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1"
CHP
011
054421
101SC1P
011-PZV-0040
1"-CHP-011054419-101SC1P-N
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1"
CHP
011
054422
101SC1P
011-PZV-0042
1"-CHP-011054424-101SC1P-N
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1"
CHP
011
054423
101SC1P
011-PZV-0066
1"-CHP-011054419-101SC1P-N
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480126
1"
CHP
011
054424
101SC1P
011-PZV-0043
1"-CHP-011054419-101SC1P-N
-
-
N
-
NEUTRALIZING AGENT
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480127
1"
CHP
011
054701
101SC1P
1"-CHP-011054721-101SC1P-N
Reducer
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
7.50
47.00
-
-
10.30
80.00
-
H
15.45
D
NO
E
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480127
2"
CHP
011
054701
101SC1P
Reducer
SA-JER-DS011-TRJR-480020
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
7.50
47.00
-
-
10.30
80.00
-
H
15.45
D
NO
E
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480020
2"
CHP
011
054701
101SC1P
SA-JER-DS011-TRJR-480127
Reducer
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
7.50
47.00
-
-
10.30
80.00
-
H
15.45
D
NO
E
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480020
1"
CHP
011
054701
101SC1P
Reducer
Insul Brk
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
7.50
47.00
-
-
10.30
80.00
-
H
15.45
D
NO
E
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480020
1"
CHP
011
054701
101SC1P
Insul Brk
24"-NAP-011011001-101CH2S-P
-
-
P
25
CORROSION INHIBITOR
Liquid
1000
7.50
47.00
-
-
10.30
80.00
-
H
15.45
D
NO
E
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480127
1"
CHP
011
054702
101SC1P
1"-CHP-011054722-101SC1P-N
Reducer
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
8.50
47.00
-
-
11.40
80.00
-
H
17.10
NFS
NO
E
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480127
2"
CHP
011
054702
101SC1P
Reducer
SA-JER-DS011-TRJR-480043
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
8.50
47.00
-
-
11.40
80.00
-
H
17.10
NFS
NO
E
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480043
2"
CHP
011
054702
101SC1P
SA-JER-DS011-TRJR-480127
Insul Brk
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
8.50
47.00
-
-
11.40
80.00
-
H
17.10
NFS
NO
E
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480043
2"
CHP
011
054702
101SC1P
Insul Brk
3"-NAP-011019008-101CH2S-P
-
-
P
25
CORROSION INHIBITOR
Liquid
1000
8.50
47.00
-
-
11.40
80.00
-
H
17.10
NFS
NO
E
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480127
1/2"
CHP
011
054720
101SC1P 1/2"-CHP-011054726-101SC1P-N
011-G-0035-B
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480127
1/2"
CHP
011
054720
101SC1P 1/2"-CHP-011054720-101SC1P-N
011-G-0035-A
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480127
1/2"
CHP
011
054720
101SC1P 1/2"-CHP-011054720-101SC1P-N
011-G-0036-B
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480127
1/2"
CHP
011
054720
101SC1P 1/2"-CHP-011054720-101SC1P-N
011-G-0036-A
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480127
2"
CHP
011
054720
101SC1P
011-D-0033
Reducer
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480127
1/2"
CHP
011
054720
101SC1P
Reducer
1/2"-CHP-011054720-101SC1P-N
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480127
1/2"
CHP
011
054720
101SC1P 1/2"-CHP-011054720-101SC1P-N 1/2"-CHP-011054720-101SC1P-N
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480127
1/2"
CHP
011
054721
101SC1P
011-G-0035-A
Reducer
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
7.50
47.00
-
-
10.30
80.00
-
H
15.45
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480127
1"
CHP
011
054721
101SC1P
Reducer
1"-CHP-011054701-101SC1P-N
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
7.50
47.00
-
-
10.30
80.00
-
H
15.45
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480127
1/2"
CHP
011
054721
101SC1P
011-G-0035-B
1/2"-CHP-011054721-101SC1P-N
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
7.50
47.00
-
-
10.30
80.00
-
H
15.45
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480127
1/2"
CHP
011
054721
101SC1P 1/2"-CHP-011054721-101SC1P-N
SA-JER-DS011-TRJR-480127
1"
CHP
011
054721
101SC1P
SA-JER-DS011-TRJR-480127
1/2"
CHP
011
054721
101SC1P 1/2"-CHP-011054721-101SC1P-N
SA-JER-DS011-TRJR-480127
1"
CHP
011
054721
101SC1P
SA-JER-DS011-TRJR-480127
1/2"
CHP
011
054722
SA-JER-DS011-TRJR-480127
1"
CHP
011
SA-JER-DS011-TRJR-480127
1/2"
CHP
SA-JER-DS011-TRJR-480127
1/2"
SA-JER-DS011-TRJR-480127
1"
SA-JER-DS011-TRJR-480127
Reducer
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
7.50
47.00
-
-
10.30
80.00
-
H
15.45
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
011-PZV-0059
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
7.50
47.00
-
-
10.30
80.00
-
H
15.45
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
Reducer
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
7.50
47.00
-
-
10.30
80.00
-
H
15.45
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
Reducer
011-PZV-0061
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
7.50
47.00
-
-
10.30
80.00
-
H
15.45
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
101SC1P
011-G-0036-A
Reducer
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
8.50
47.00
-
-
11.40
80.00
-
H
17.10
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
054722
101SC1P
Reducer
1"-CHP-011054702-101SC1P-N
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
8.50
47.00
-
-
11.40
80.00
-
H
17.10
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
011
054722
101SC1P
011-G-0036-B
1/2"-CHP-011054722-101SC1P-N
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
8.50
47.00
-
-
11.40
80.00
-
H
17.10
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
CHP
011
054722
101SC1P 1/2"-CHP-011054722-101SC1P-N
CHP
011
054722
101SC1P
1/2"
CHP
011
054722
101SC1P 1/2"-CHP-011054722-101SC1P-N
SA-JER-DS011-TRJR-480127
1"
CHP
011
054722
101SC1P
SA-JER-DS011-TRJR-480127
1/2"
CHP
011
054723
SA-JER-DS011-TRJR-480127
2"
CHP
011
SA-JER-DS011-TRJR-480127
2"
CHP
SA-JER-DS011-TRJR-480127
2"
SA-JER-DS011-TRJR-480127
2"
SA-JER-DS011-TRJR-480127
Reducer
Reducer
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
8.50
47.00
-
-
11.40
80.00
-
H
17.10
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
011-PZV-0058
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
8.50
47.00
-
-
11.40
80.00
-
H
17.10
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
Reducer
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
8.50
47.00
-
-
11.40
80.00
-
H
17.10
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
011-PZV-0060
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
8.50
47.00
-
-
11.40
80.00
-
H
17.10
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
101SC1P 1/2"-CHP-011054720-101SC1P-N 1/2"-CHP-011054720-101SC1P-N
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
054724
101SC1P
011-D-0033
2"-CHP-011054724-101SC1P-N
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
011
054724
101SC1P
011-D-0033
2"-CHP-011054724-101SC1P-N
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
CHP
011
054724
101SC1P
2"-CHP-011054724-101SC1P-N
DRIP PAN
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
NO
E
Y
POTENTIAL
N
N
N
N
-
-
CHP
011
054725
101SC1P
Blind flange
011-D-0033
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
2"
CHP
011
054726
101SC1P
011-D-0033
Reducer
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480127
1/2"
CHP
011
054726
101SC1P
Reducer
1/2"-CHP-011054720-101SC1P-N
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480127
1"
CHP
011
054727
101SC1P
011-PZV-0059
Reducer
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480127
2"
CHP
011
054727
101SC1P
Reducer
011-D-0033
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480127
1"
CHP
011
054727
101SC1P
011-PZV-0061
1"-CHP-011054727-101SC1P-N
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480127
1"
CHP
011
054727
101SC1P
011-PZV-0058
1"-CHP-011054727-101SC1P-N
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
SA-JER-DS011-TRJR-480127
1"
CHP
011
054727
101SC1P
011-PZV-0060
1"-CHP-011054727-101SC1P-N
-
-
N
-
CORROSION INHIBITOR
Liquid
1000
0.00
47.00
-
-
3.50
80.00
-
H
5.25
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480128
1"
CHP
011
054801
101SD0P
1"-CHP-011054830-101SD0P-N
SA-JER-DS011-TRJR-480105
-
-
N
-
PHOSPHATE
Liquid
1000
6.00
47.00
-
-
9.30
80.00
-
H
13.95
D
NO
E
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
1"
CHP
011
054801
101SD0P
SA-JER-DS011-TRJR-480128
Insul Brk
-
-
N
-
PHOSPHATE
Liquid
1000
6.00
47.00
-
-
9.30
80.00
-
H
13.95
D
NO
E
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
1"
CHP
011
054801
101SD0P
Insul Brk
3"-BFW-011040302-101CS1P-P
-
-
P
25
PHOSPHATE
Liquid
1000
6.00
47.00
-
-
9.30
80.00
-
H
13.95
D
NO
E
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480128
1/2"
CHP
011
054830
101SD0P
011-G-0037-A
Reducer
-
-
N
-
PHOSPHATE
Liquid
1000
6.00
47.00
-
-
9.30
80.00
-
H
13.95
D
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480128
1"
CHP
011
054830
101SD0P
Reducer
1"-CHP-011054801-101SD0P-N
-
-
N
-
PHOSPHATE
Liquid
1000
6.00
47.00
-
-
9.30
80.00
-
H
13.95
D
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480128
1/2"
CHP
011
054830
101SD0P
011-G-0037-B
1/2"-CHP-011054830-101SD0P-N
-
-
N
-
PHOSPHATE
Liquid
1000
6.00
47.00
-
-
9.30
80.00
-
H
13.95
D
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480128
1/2"
CHP
011
054830
101SD0P 1/2"-CHP-011054830-101SD0P-N
Reducer
-
-
N
-
PHOSPHATE
Liquid
1000
6.00
47.00
-
-
9.30
80.00
-
H
13.95
D
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480128
1"
CHP
011
054830
101SD0P
011-PZV-0056
-
-
N
-
PHOSPHATE
Liquid
1000
6.00
47.00
-
-
9.30
80.00
-
H
13.95
D
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480128
1/2"
CHP
011
054830
101SD0P 1/2"-CHP-011054830-101SD0P-N
Reducer
-
-
N
-
PHOSPHATE
Liquid
1000
6.00
47.00
-
-
9.30
80.00
-
H
13.95
D
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480128
1"
CHP
011
054830
101SD0P
011-PZV-0057
-
-
N
-
PHOSPHATE
Liquid
1000
6.00
47.00
-
-
9.30
80.00
-
H
13.95
D
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480128
1/2"
CHP
011
054831
101SD0P 1/2"-CHP-011054832-101SD0P-N
011-G-0037-A
-
-
N
-
PHOSPHATE
Liquid
1000
0.00
47.00
-
-
7.00
80.00
-
H
10.50
D
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480128
1/2"
CHP
011
054831
101SD0P 1/2"-CHP-011054831-101SD0P-N
SA-JER-DS011-TRJR-480128
2"
CHP
011
054831
101SD0P
SA-JER-DS011-TRJR-480128
1/2"
CHP
011
054831
SA-JER-DS011-TRJR-480128
2"
CHP
011
054832
SA-JER-DS011-TRJR-480128
1/2"
CHP
011
SA-JER-DS011-TRJR-480128
2"
CHP
SA-JER-DS011-TRJR-480128
2"
SA-JER-DS011-TRJR-480128
Reducer
Reducer
Reducer
Reducer
-
011-G-0037-B
-
-
N
-
PHOSPHATE
Liquid
1000
0.00
47.00
-
-
7.00
80.00
-
H
10.50
D
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
011-D-0034
Reducer
-
-
N
-
PHOSPHATE
Liquid
1000
0.00
47.00
-
-
7.00
80.00
-
H
10.50
D
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
101SD0P
Reducer
1/2"-CHP-011054831-101SD0P-N
-
-
N
-
PHOSPHATE
Liquid
1000
0.00
47.00
-
-
7.00
80.00
-
H
10.50
D
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
101SD0P
011-D-0034
Reducer
-
-
N
-
PHOSPHATE
Liquid
1000
0.00
47.00
-
-
7.00
80.00
-
H
10.50
D
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
054832
101SD0P
Reducer
1/2"-CHP-011054831-101SD0P-N
-
-
N
-
PHOSPHATE
Liquid
1000
0.00
47.00
-
-
7.00
80.00
-
H
10.50
D
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
011
054833
101SD0P
011-D-0034
2"-CHP-011054833-101SD0P-N
-
-
N
-
PHOSPHATE
Liquid
1000
0.00
47.00
-
-
7.00
80.00
-
H
10.50
D
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
CHP
011
054833
101SD0P
2"-CHP-011054833-101SD0P-N
DRIP PAN
-
-
N
-
PHOSPHATE
Liquid
1000
0.00
47.00
-
-
7.00
80.00
-
H
10.50
D
NO
E
N
N
N
N
N
N
-
-
2"
CHP
011
054833
101SD0P
011-D-0034
2"-CHP-011054833-101SD0P-N
-
-
N
-
PHOSPHATE
Liquid
1000
0.00
47.00
-
-
7.00
80.00
-
H
10.50
D
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480128
2"
CHP
011
054834
101SD0P
Blind flange
011-D-0034
-
-
N
-
PHOSPHATE
Liquid
1000
0.00
47.00
-
-
7.00
80.00
-
H
10.50
D
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480128
1"
CHP
011
054840
101SD0P
011-PZV-0056
1"-CHP-011054841-101SD0P-N
-
-
N
-
PHOSPHATE
Liquid
1000
0.00
47.00
-
-
7.00
80.00
-
H
10.50
D
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480128
2"
CHP
011
054841
101SD0P
Reducer
011-D-0034
-
-
N
-
PHOSPHATE
Liquid
1000
0.00
47.00
-
-
7.00
80.00
-
H
10.50
D
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480128
1"
CHP
011
054841
101SD0P
011-PZV-0057
Reducer
-
-
N
-
PHOSPHATE
Liquid
1000
0.00
47.00
-
-
7.00
80.00
-
H
10.50
D
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
SA-JER-DS011-TRJR-480003
2"
CLD
011
001301
101CH2S
2"-CRU-011001022-106CS1P-P
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
40.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
001301
101CH2S
SA-JER-DS011-TRJR-480003
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
40.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
4"
CLD
011
001301
101CH2S
Insul Brk
4"-CLD-011001313-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
40.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480002
2"
CLD
011
001303
101CH2S
2"-CRU-011001010-106CS1P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
001303
101CH2S
SA-JER-DS011-TRJR-480002
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 16 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
4"-CLD-011025304-101CH2S-N
-
-
N
-
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
(NOTE 7)
SA-JER-DS011-TRJR-480229
4"
CLD
011
001303
101CH2S
Insul Brk
SA-JER-DS011-TRJR-480002
2"
CLD
011
001304
101CH2S
2"-CRU-011001011-106CS1P-N
SA-JER-DS011-TRJR-480229
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
40.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
001304
101CH2S
SA-JER-DS011-TRJR-480002
4"-CLD-011001304-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
40.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
4"
CLD
011
001304
101CH2S
2"-CLD-011001304-101CH2S-N
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480001
2"
CLD
011
001307
101CH2S
2"-SLP-011001001-103CS1P-N
SA-JER-DS011-TRJR-480229
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
001307
101CH2S
SA-JER-DS011-TRJR-480001
4"-CLD-011001307-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
4"
CLD
011
001307
101CH2S
2"-CLD-011001307-101CH2S-N
4"-CLD-011025304-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480002
2"
CLD
011
001308
101CH2S
2"-CRU-011001013-106CS1P-N
SA-JER-DS011-TRJR-480228
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
40.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
2"
CLD
011
001308
101CH2S
SA-JER-DS011-TRJR-480002
4"-CLD-011001308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
40.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
4"
CLD
011
001308
101CH2S
2"-CLD-011001308-101CH2S-N
6"-CLD-011078316-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480002
2"
CLD
011
001309
101CH2S
2"-CRU-011001012-106CS1P-N
SA-JER-DS011-TRJR-480228
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
40.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
2"
CLD
011
001309
101CH2S
SA-JER-DS011-TRJR-480002
4"-CLD-011001309-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
40.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
4"
CLD
011
001309
101CH2S
2"-CLD-011001309-101CH2S-N
6"-CLD-011078316-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480003
2"
CLD
011
001310
101CH2S
2"-JET-011001002-103CS1P-P
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
001310
101CH2S
SA-JER-DS011-TRJR-480003
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
4"
CLD
011
001310
101CH2S
Insul Brk
4"-CLD-011001304-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480003
2"
CLD
011
001312
101CH2S
2"-HFO-011001002-103CS1P-P
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
001312
101CH2S
SA-JER-DS011-TRJR-480003
2"-CLD-011001313-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480003
2"
CLD
011
001313
101CH2S
2"-CRU-011001023-106CS1P-P
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
001313
101CH2S
SA-JER-DS011-TRJR-480003
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
4"
CLD
011
001313
101CH2S
Insul Brk
4"-CLD-011001304-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480004
2"
CLD
011
002301
101CH2S
2"-CRU-011002003-106CS1P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
002301
101CH2S
SA-JER-DS011-TRJR-480004
3"-CLD-011002304-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480004
2"
CLD
011
002302
101CH2S
2"-NAP-011002002-101CH2S-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
002302
101CH2S
SA-JER-DS011-TRJR-480004
3"-CLD-011002304-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480004
2"
CLD
011
002303
101CH2S
2"-CRU-011002004-106CS1P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
002303
101CH2S
SA-JER-DS011-TRJR-480004
3"-CLD-011002304-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480004
2"
CLD
011
002304
101CH2S
2"-NAP-011002003-101CH2S-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
002304
101CH2S
SA-JER-DS011-TRJR-480004
Reducer
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
3"
CLD
011
002304
101CH2S
Reducer
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
002304
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480004
2"
CLD
011
002305
101CH2S
2"-CRU-011002005-106CS1P-N
SA-JER-DS011-TRJR-480227
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
56.80
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
002305
101CH2S
SA-JER-DS011-TRJR-480004
3"-CLD-011002304-101CH2S-P
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
56.80
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480004
2"
CLD
011
002306
101CH2S
2"-CRU-011002008-106CS1P-N
SA-JER-DS011-TRJR-480227
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
56.80
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
002306
101CH2S
SA-JER-DS011-TRJR-480004
3"-CLD-011002304-101CH2S-P
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
56.80
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480004
2"
CLD
011
002307
101CH2S
2"-CRU-011002011-106CS1P-P
SA-JER-DS011-TRJR-480227
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
002307
101CH2S
SA-JER-DS011-TRJR-480004
2"-CLD-011002301-101CH2S-P
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480004
2"
CLD
011
002308
101CH2S
2"-CRU-011002012-106CS1P-P
SA-JER-DS011-TRJR-480227
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
002308
101CH2S
SA-JER-DS011-TRJR-480004
2"-CLD-011002303-101CH2S-P
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480002
2"
CLD
011
002309
101CH2S
2"-SLP-011002001-103CS1P-P
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
82.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
002309
101CH2S
SA-JER-DS011-TRJR-480002
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
82.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
4"
CLD
011
002309
101CH2S
Insul Brk
4"-CLD-011025306-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480005
2"
CLD
011
003301
101CH2S
2"-CRU-011003004-106CS1P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
003301
101CH2S
SA-JER-DS011-TRJR-480005
3"-CLD-011003301-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
3"
CLD
011
003301
101CH2S
Reducer
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
003301
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480005
2"
CLD
011
003302
101CH2S
2"-NAP-011003002-101CH2S-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
003302
101CH2S
SA-JER-DS011-TRJR-480005
3"-CLD-011003301-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 17 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
2"-CRU-011003005-106CS1P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
(NOTE 7)
SA-JER-DS011-TRJR-480005
2"
CLD
011
003303
101CH2S
SA-JER-DS011-TRJR-480230
2"
CLD
011
003303
101CH2S
SA-JER-DS011-TRJR-480005
3"-CLD-011003301-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480005
2"
CLD
011
003304
101CH2S
2"-NAP-011003003-101CH2S-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
003304
101CH2S
SA-JER-DS011-TRJR-480005
Reducer
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480005
2"
CLD
011
003305
101CH2S
2"-CRU-011003006-106CS1P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
003305
101CH2S
SA-JER-DS011-TRJR-480005
3"-CLD-011003301-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480006
2"
CLD
011
003309
101CH2S
2"-CRU-011003008-106CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
003309
101CH2S
SA-JER-DS011-TRJR-480006
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
003309
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480006
2"
CLD
011
003310
101CH2S
2"-CRU-011003009-106CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
003310
101CH2S
SA-JER-DS011-TRJR-480006
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
003310
101CH2S
Insul Brk
4"-CLD-011004301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480006
2"
CLD
011
003312
101CH2S
2"-DIE-011003003-103CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
003312
101CH2S
SA-JER-DS011-TRJR-480006
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
003312
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480005
2"
CLD
011
003313
101CH2S
2"-CRU-011003013-106CS1P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
003313
101CH2S
SA-JER-DS011-TRJR-480005
3"-CLD-011003301-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480005
2"
CLD
011
003314
101CH2S
2"-CRU-011003014-106CS1P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
003314
101CH2S
SA-JER-DS011-TRJR-480005
3"-CLD-011003301-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480006
2"
CLD
011
003315
101CH2S
2"-DIE-011003004-103CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
003315
101CH2S
SA-JER-DS011-TRJR-480006
4"-CLD-011003315-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
003315
101CH2S
2"-CLD-011003315-101CH2S-P
4"-CLD-011003310-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480005
2"
CLD
011
003316
101CH2S
2"-CRU-011003015-106CS1P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
003316
101CH2S
SA-JER-DS011-TRJR-480005
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
003316
101CH2S
Insul Brk
6"-CLD-011078308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480006
2"
CLD
011
003317
101CH2S
2"-CRU-011003016-106CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
003317
101CH2S
SA-JER-DS011-TRJR-480006
2"-CLD-011010301-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480008
2"
CLD
011
004301
101CH2S
2"-JET-011004004-101CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
004301
101CH2S
SA-JER-DS011-TRJR-480008
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
004301
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480008
2"
CLD
011
004302
101CH2S
2"-JET-011004003-101CS1P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
004302
101CH2S
SA-JER-DS011-TRJR-480008
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
004302
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480008
2"
CLD
011
004304
101CH2S
2"-CRU-011004003-106CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
004304
101CH2S
SA-JER-DS011-TRJR-480008
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
004304
101CH2S
Insul Brk
4"-CLD-011004301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480008
2"
CLD
011
004305
101CH2S
2"-CRU-011004004-106CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
004305
101CH2S
SA-JER-DS011-TRJR-480008
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
004305
101CH2S
Insul Brk
4"-CLD-011004304-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480008
2"
CLD
011
004306
101CH2S
2"-JET-011004005-101CS1P-P
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
004306
101CH2S
SA-JER-DS011-TRJR-480008
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
4"
CLD
011
004306
101CH2S
Insul Brk
4"-CLD-011005307-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480007
2"
CLD
011
004307
101CH2S
2"-DIE-011004002-103CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
004307
101CH2S
SA-JER-DS011-TRJR-480007
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
004307
101CH2S
Insul Brk
4"-CLD-011003310-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480008
2"
CLD
011
004309
101CH2S
2"-JET-011004006-101CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
004309
101CH2S
SA-JER-DS011-TRJR-480008
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
004309
101CH2S
Insul Brk
4"-CLD-011004304-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 18 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
SA-JER-DS011-TRJR-480216
-
-
P
25
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
200.00
-
H
5.25
NFS
YES
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480007
2"
CLD
011
004310
101CH2S
2"-CRU-011004006-106CS1P-P
SA-JER-DS011-TRJR-480216
2"
CLD
011
004310
101CH2S
SA-JER-DS011-TRJR-480007
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480216
4"
CLD
011
004310
101CH2S
Insul Brk
4"-CLD-011004301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480008
2"
CLD
011
004311
101CH2S
2"-JET-011004007-101CS1P-P
SA-JER-DS011-TRJR-480228
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480228
2"
CLD
011
004311
101CH2S
SA-JER-DS011-TRJR-480008
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480228
4"
CLD
011
004311
101CH2S
Insul Brk
6"-CLD-011078316-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
SA-JER-DS011-TRJR-480010
2"
CLD
011
005301
101CH2S
2"-CRU-011005004-106CS1P-P
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
005301
101CH2S
SA-JER-DS011-TRJR-480010
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
005301
101CH2S
Insul Brk
4"-CLD-011005302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480010
2"
CLD
011
005302
101CH2S
2"-CRU-011005005-106CS1P-P
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
005302
101CH2S
SA-JER-DS011-TRJR-480010
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
005302
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480010
2"
CLD
011
005305
101CH2S
2"-HFO-011005006-103CL2P-P
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
005305
101CH2S
SA-JER-DS011-TRJR-480010
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
005305
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
SA-JER-DS011-TRJR-480010
2"
CLD
011
005306
101CH2S
2"-HFO-011005007-103CL2P-P
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
005306
101CH2S
SA-JER-DS011-TRJR-480010
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
005306
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480009
2"
CLD
011
005307
101CH2S
2"-CRU-011005013-106CS1P-P
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
005307
101CH2S
SA-JER-DS011-TRJR-480009
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
005307
101CH2S
Insul Brk
4"-CLD-011005308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
SA-JER-DS011-TRJR-480009
2"
CLD
011
005308
101CH2S
2"-JET-011005002-103CS1P-P
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
005308
101CH2S
SA-JER-DS011-TRJR-480009
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
005308
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480010
2"
CLD
011
005309
101CH2S
2"-CRU-011005016-106CS1P-P
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
005309
101CH2S
SA-JER-DS011-TRJR-480010
2"-CLD-011005301-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480010
2"
CLD
011
005310
101CH2S
2"-CRU-011005017-106CS1P-P
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
005310
101CH2S
SA-JER-DS011-TRJR-480010
2"-CLD-011005302-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480010
2"
CLD
011
005311
101CH2S
2"-HFO-011005011-103CL2P-P
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
005311
101CH2S
SA-JER-DS011-TRJR-480010
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
005311
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
N
SA-JER-DS011-TRJR-480010
2"
CLD
011
005312
101CH2S
2"-HFO-011005010-103CL2P-P
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
005312
101CH2S
SA-JER-DS011-TRJR-480010
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
005312
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
N
N
N
N
SA-JER-DS011-TRJR-480010
2"
CLD
011
006301
101CH2S
2"-CRU-011006005-106CS1P-P
SA-JER-DS011-TRJR-480228
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480228
2"
CLD
011
006301
101CH2S
SA-JER-DS011-TRJR-480010
2"-CLD-011007301-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480011
4"
CLD
011
006302
101CH2S
4"-CLD-011006309-103CS4P-P
SA-JER-DS011-TRJR-480228
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480228
4"
CLD
011
006302
101CH2S
SA-JER-DS011-TRJR-480011
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480228
4"
CLD
011
006302
101CH2S
Insul Brk
6"-CLD-011078316-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
2"
CLD
011
006303
103CH2S
011-D-0001
Reducer
-
-
H
40
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
1"
CLD
011
006303
103CH2S
Reducer
Reducer
-
-
H
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
1"
CLD
011
006303
103CH2S
Reducer
1"-CLD-011006303-103CH2S-H
-
-
H
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
1"
CLD
011
006303
103CH2S
Reducer
1"-CLD-011006303-103CH2S-H
-
-
H
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
1"
CLD
011
006303
103CH2S
Reducer
1"-CLD-011006303-103CH2S-H
-
-
H
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
2"
CLD
011
006303
103CH2S
011-D-0001
Reducer
-
-
H
40
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
1"
CLD
011
006303
103CH2S
Reducer
1"-CLD-011006303-103CH2S-H
-
-
H
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
2"
CLD
011
006303
103CH2S
011-D-0001
Reducer
-
-
H
40
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
2"
CLD
011
006303
103CH2S
011-D-0001
Reducer
-
-
H
40
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
Q
Y
N
N
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
-
N
N
-
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
N
N
-
N
N
N
N
-
N
N
N
N
N
-
N
N
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 19 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
011-D-0001
Reducer
-
-
H
40
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
Liquid
917
13.50
148.00
-
-
PRESS. (BARG)
178.00
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
-
H
24.00
NFS
SA-JER-DS011-TRJR-480011
2"
CLD
011
006303
103CH2S
SA-JER-DS011-TRJR-480011
3/4"
CLD
011
006303
103CH2S
Reducer
Insul Brk
-
-
H
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
SA-JER-DS011-TRJR-480011
3/4"
CLD
011
006303
103CH2S
Insul Brk
Reducer
-
-
P
25
HC CLOSED DRAIN
Liquid
917
0.50
170.00
-
-
16.00
178.00
-
H
24.00
HC CLOSED DRAIN
16.00
TEMP. (ºC)
STRESS TEMP
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
YES
M or Q
Y
N
N
N
N
N
-
NFS
YES
M or Q
Y
N
N
N
N
N
-
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
1"
CLD
011
006303
103CH2S
Reducer
Reducer
-
-
P
25
HC CLOSED DRAIN
Liquid
917
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
3/4"
CLD
011
006303
103CH2S
1"-CLD-011006303-103CH2S-P
3/4"-OLW-011006301-101CS1PN
-
-
P
25
HC CLOSED DRAIN
Liquid
917
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
Q
Y
N
N
N
N
N
-
Reducer
2"-CLD-011006306-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
917
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
Q
Y
N
N
N
N
N
-
-
H
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
2"
CLD
011
006303
103CH2S
SA-JER-DS011-TRJR-480011
3/4"
CLD
011
006304
103CS1P
1"-CLD-011006303-103CH2S-H
011-SC-0009
-
SA-JER-DS011-TRJR-480274
3/4"
CLD
011
006304
103CS1P
1"-CLD-011006303-103CH2S-H
SC-0009
-
-
H
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
3/4"
CLD
011
006305
103CS1P
011-SC-0009
SA-JER-DS011-TRJR-480274
3/4"
CLD
011
006305
103CS1P 1/2"-CLD-011200313-103CS1P-N
SA-JER-DS011-TRJR-480011
2"
CLD
011
006306
101CH2S
SA-JER-DS011-TRJR-480228
2"
CLD
011
006306
101CH2S
1"-CLD-011006303-103CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
917
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
Q
Y
N
N
N
N
N
-
1"-CLD-011006303-103CH2S-H
-
-
P
25
HC CLOSED DRAIN
Liquid
917
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
Q
Y
N
N
N
N
N
-
2"-CLD-011006303-103CH2S-P
SA-JER-DS011-TRJR-480228
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
4"
CLD
011
006306
101CH2S
Insul Brk
6"-CLD-011078316-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
1/2"
CLD
011
006307
103CH2S
011-D-0001
Reducer
-
-
P
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M
Y
N
N
N
N
N
-
Reducer
Reducer
-
-
P
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M
Y
N
N
N
N
N
-
-
P
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
1"
CLD
011
006307
103CH2S
SA-JER-DS011-TRJR-480011
3/4"
CLD
011
006307
103CH2S
1"-CLD-011006307-103CH2S-P
Blind flange
-
SA-JER-DS011-TRJR-480011
2"
CLD
011
006307
103CH2S
Reducer
2"-CLD-011006308-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
1/2"
CLD
011
006307
103CH2S
011-D-0001
1"-CLD-011006307-103CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
1/2"
CLD
011
006307
103CH2S
011-D-0001
1"-CLD-011006307-103CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
2"
CLD
011
006308
101CH2S
2"-CLD-011006307-103CH2S-P
SA-JER-DS011-TRJR-480228
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
2"
CLD
011
006308
101CH2S
SA-JER-DS011-TRJR-480011
2"-CLD-011006306-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
3"
CLD
011
006309
103CS4P
011-D-0001
Reducer
-
-
P
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
3"
CLD
011
006309
103CS4P
011-D-0001
4"-CLD-011006309-103CS4P-P
-
-
P
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
4"
CLD
011
006309
103CS4P
011-D-0001
4"-CLD-011006309-103CS4P-P
-
-
P
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
3"
CLD
011
006309
103CS4P
011-D-0001
4"-CLD-011006309-103CS4P-P
-
-
P
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
3"
CLD
011
006309
103CS4P
011-D-0001
4"-CLD-011006309-103CS4P-P
-
-
P
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
3"
CLD
011
006309
103CS4P
011-D-0001
4"-CLD-011006309-103CS4P-P
-
-
P
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
4"
CLD
011
006309
103CS4P
011-D-0001
4"-CLD-011006309-103CS4P-P
-
-
P
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
3"
CLD
011
006309
103CS4P
011-D-0001
4"-CLD-011006309-103CS4P-P
-
-
P
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
4"
CLD
011
006309
103CS4P
Reducer
4"-CLD-011006302-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
1"
CLD
011
006309
103CS4P
4"-CLD-011006309-103CS4P-P
1"-OLW-011006306-101CS1P-N
-
-
P
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
Reducer
SA-JER-DS011-TRJR-480011
1"
CLD
011
006310
103CS4P
SA-JER-DS011-TRJR-480011
3/4"
CLD
011
006311
103CH2S 3/4"-CRU-011006013-103CS2P-H
4"-CLD-011006309-103CS4P-P
-
-
P
25
HC CLOSED DRAIN
Liquid
917
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
1"-CLD-011006303-103CH2S-P
-
-
H
40
HC CLOSED DRAIN
Liquid
1000
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
N or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
3/4"
CLD
011
006311
103CH2S
SA-JER-DS011-TRJR-480011
3/4"
CLD
011
006311
3/4"-CLD-011006311-103CH2S-H
-
-
H
40
HC CLOSED DRAIN
Liquid
1000
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
N or Q
Y
N
N
N
N
N
-
103CH2S 3/4"-CRU-011006013-103CS2P-H 3/4"-CLD-011006311-103CH2S-H
-
-
H
40
HC CLOSED DRAIN
Liquid
1000
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
N or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
3/4"
CLD
011
006311
SA-JER-DS011-TRJR-480013
2"
CLD
011
007301
103CH2S 3/4"-CRU-011006013-103CS2P-H 3/4"-CLD-011006311-103CH2S-H
-
-
H
40
HC CLOSED DRAIN
Liquid
1000
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
N or Q
Y
N
N
N
N
N
-
101CH2S
2"-CRU-011007004-106CS2P-P
SA-JER-DS011-TRJR-480228
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
2"
CLD
011
SA-JER-DS011-TRJR-480228
4"
CLD
011
007301
101CH2S
SA-JER-DS011-TRJR-480013
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
007301
101CH2S
Insul Brk
6"-CLD-011078316-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
4"
CLD
SA-JER-DS011-TRJR-480231
4"
CLD
011
007302
101CH2S
4"-CLD-011007309-103CS4P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
011
007302
101CH2S
SA-JER-DS011-TRJR-480012
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
SA-JER-DS011-TRJR-480013
2"
CLD
011
007302
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
CLD
011
007303
101CH2S
2"-BRN-011007007-106CS2P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
SA-JER-DS011-TRJR-480231
2"
CLD
011
007303
101CH2S
SA-JER-DS011-TRJR-480013
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
4"
CLD
011
007303
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480013
2"
CLD
011
007304
101CH2S
2"-BRN-011007006-106CS2P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
007304
101CH2S
SA-JER-DS011-TRJR-480013
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
011-LT-0113
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 20 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480231
4"
CLD
011
007304
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
2"
CLD
011
007305
103CH2S
011-D-0002
Reducer
-
-
H
40
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
2"
CLD
011
007305
103CH2S
011-D-0002
Reducer
-
-
H
40
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
2"
CLD
011
007305
103CH2S
011-D-0002
Reducer
-
-
H
40
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
2"
CLD
011
007305
103CH2S
011-D-0002
Reducer
-
-
H
40
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
2"
CLD
011
007305
103CH2S
011-D-0002
Reducer
-
-
H
40
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
1"
CLD
011
007305
103CH2S
Reducer
Reducer
-
-
H
25
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
1"
CLD
011
007305
103CH2S
Reducer
1"-CLD-011007305-103CH2S-H
-
-
H
25
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
1"
CLD
011
007305
103CH2S
Reducer
1"-CLD-011007305-103CH2S-H
-
-
H
25
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
1"
CLD
011
007305
103CH2S
Reducer
1"-CLD-011007305-103CH2S-H
-
-
H
25
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
1"
CLD
011
007305
103CH2S
Reducer
1"-CLD-011007305-103CH2S-H
-
-
H
25
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
3/4"
CLD
011
007305
103CH2S
Reducer
Insul Brk
-
-
H
25
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
3/4"
CLD
011
007305
103CH2S
Insul Brk
Reducer
-
-
P
25
HC CLOSED DRAIN
Liquid
922
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
1"
CLD
011
007305
103CH2S
Reducer
Reducer
-
-
P
25
HC CLOSED DRAIN
Liquid
922
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
3/4"
CLD
011
007305
103CH2S
1"-CLD-011007305-103CH2S-P
3/4"-OLW-011007301-101CS1PN
-
-
P
25
HC CLOSED DRAIN
Liquid
922
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
2"
CLD
011
007305
103CH2S
Reducer
2"-CLD-011007308-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
922
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
3/4"
CLD
011
007306
103CS1P
1"-CLD-011007305-103CH2S-H
011-SC-0010
-
-
H
25
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480274
3/4"
CLD
011
007306
103CS1P
1"-CLD-011007305-103CH2S-H
SC-0010
-
-
H
25
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
2"
CLD
011
007308
101CH2S
2"-CLD-011007305-103CH2S-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
007308
101CH2S
SA-JER-DS011-TRJR-480012
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
007308
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
3"
CLD
011
007309
103CS4P
011-D-0002
Reducer
-
-
P
25
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
1"
CLD
011
007309
103CS4P
4"-CLD-011007309-103CS4P-P
1"-OLW-011007302-101CS1P-N
-
-
P
25
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
3"
CLD
011
007309
103CS4P
011-D-0002
4"-CLD-011007309-103CS4P-P
-
-
P
25
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
3"
CLD
011
007309
103CS4P
011-D-0002
4"-CLD-011007309-103CS4P-P
-
-
P
25
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
4"
CLD
011
007309
103CS4P
011-D-0002
4"-CLD-011007309-103CS4P-P
-
-
P
25
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
3"
CLD
011
007309
103CS4P
011-D-0002
4"-CLD-011007309-103CS4P-P
-
-
P
25
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
3"
CLD
011
007309
103CS4P
011-D-0002
4"-CLD-011007309-103CS4P-P
-
-
P
25
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
4"
CLD
011
007309
103CS4P
011-D-0002
4"-CLD-011007309-103CS4P-P
-
-
P
25
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
3"
CLD
011
007309
103CS4P
011-D-0002
4"-CLD-011007309-103CS4P-P
-
-
P
25
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
4"
CLD
011
007309
103CS4P
Reducer
4"-CLD-011007302-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
1"
CLD
011
007310
103CS4P
Reducer
011-LG-0159
-
-
P
25
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
1"
CLD
011
007310
103CS4P
011-LG-0159
4"-CLD-011007309-103CS4P-P
-
-
P
25
HC CLOSED DRAIN
Liquid
922
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
3/4"
CLD
011
007311
103CH2S 3/4"-CRU-011007015-103CS1P-H
1"-CLD-011007305-103CH2S-P
-
-
H
40
HC CLOSED DRAIN
Liquid
1000
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
N or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
3/4"
CLD
011
007311
103CH2S 3/4"-CRU-011007015-103CS1P-H 3/4"-CLD-011007311-103CH2S-H
-
-
H
40
HC CLOSED DRAIN
Liquid
1000
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
N or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
3/4"
CLD
011
007311
103CH2S
3/4"-CLD-011007311-103CH2S-H
-
-
H
40
HC CLOSED DRAIN
Liquid
1000
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
N or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
3/4"
CLD
011
007311
103CH2S 3/4"-CRU-011007015-103CS1P-H 3/4"-CLD-011007311-103CH2S-H
-
-
H
40
HC CLOSED DRAIN
Liquid
1000
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
N or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
1/2"
CLD
011
007312
103CH2S
011-D-0002
Reducer
-
-
P
25
HC CLOSED DRAIN
Liquid
917
12.00
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
1"
CLD
011
007312
103CH2S
Reducer
Reducer
-
-
P
25
HC CLOSED DRAIN
Liquid
917
12.00
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
3/4"
CLD
011
007312
103CH2S
1"-CLD-011007312-103CH2S-P
Blind flange
-
-
P
25
HC CLOSED DRAIN
Liquid
917
12.00
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
2"
CLD
011
007312
103CH2S
Reducer
2"-CLD-011007313-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
917
12.00
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
1/2"
CLD
011
007312
103CH2S
011-D-0002
1"-CLD-011007312-103CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
917
12.00
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
1/2"
CLD
011
007312
103CH2S
011-D-0002
1"-CLD-011007312-103CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
917
12.00
148.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
2"
CLD
011
007313
101CH2S
2"-CLD-011007312-103CH2S-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
007313
101CH2S
SA-JER-DS011-TRJR-480012
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
011-LT-0114
SA-JER-DS011-TRJR-480231
4"
CLD
011
007313
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
3/4"
CLD
011
007314
103CS1P
011-SC-0010
1"-CLD-011007305-103CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
922
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 21 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
1"-CLD-011007305-103CH2S-H
-
-
P
25
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
Liquid
922
0.50
170.00
-
-
16.00
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
178.00
-
H
24.00
NFS
YES
Q
Y
N
N
N
N
N
-
(NOTE 7)
SA-JER-DS011-TRJR-480274
3/4"
CLD
011
007314
103CS1P 1/2"-CLD-011200314-103CS1P-N
SA-JER-DS011-TRJR-480015
2"
CLD
011
008303
101CH2S
2"-CRU-011008008-103CS1P-P
SA-JER-DS011-TRJR-480228
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
2"
CLD
011
008303
101CH2S
SA-JER-DS011-TRJR-480015
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
4"
CLD
011
008303
101CH2S
Insul Brk
6"-CLD-011078316-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480015
2"
CLD
011
008304
101CH2S
2"-CRU-011008009-103CS1P-P
SA-JER-DS011-TRJR-480228
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
2"
CLD
011
008304
101CH2S
SA-JER-DS011-TRJR-480015
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
4"
CLD
011
008304
101CH2S
Insul Brk
6"-CLD-011078316-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480016
2"
CLD
011
008305
101CH2S
2"-CRU-011008010-103CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480016
2"
CLD
011
008305
101CH2S
2"-HFO-011008017-103CS1P-S
2"-CLD-011008305-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
100
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
008305
101CH2S
SA-JER-DS011-TRJR-480016
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
008305
101CH2S
Insul Brk
6"-CLD-011078318-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480016
2"
CLD
011
008306
101CH2S
2"-HFO-011008003-103CS1P-S
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
008306
101CH2S
SA-JER-DS011-TRJR-480016
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
008306
101CH2S
Insul Brk
6"-CLD-011078318-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480016
2"
CLD
011
008308
101CH2S
2"-CRU-011008020-103CS1P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
100
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
008308
101CH2S
SA-JER-DS011-TRJR-480016
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
008308
101CH2S
Insul Brk
6"-CLD-011078308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480015
2"
CLD
011
008309
101CH2S
2"-CRU-011008021-103CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
008309
101CH2S
SA-JER-DS011-TRJR-480015
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
008309
101CH2S
Insul Brk
4"-CLD-011004301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480017
2"
CLD
011
009301
101CH2S
2"-CRU-011009002-103CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
009301
101CH2S
SA-JER-DS011-TRJR-480017
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
009301
101CH2S
Insul Brk
6"-CLD-011078318-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480017
2"
CLD
011
009303
101CH2S
2"-HFO-011009003-103CL2P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
009303
101CH2S
SA-JER-DS011-TRJR-480017
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
009303
101CH2S
Insul Brk
4"-CLD-011010301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480017
2"
CLD
011
009304
101CH2S
2"-CRU-011009004-103CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
009304
101CH2S
SA-JER-DS011-TRJR-480017
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
009304
101CH2S
Insul Brk
4"-CLD-011009301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480017
2"
CLD
011
009305
101CH2S
2"-DIE-011009002-103CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
009305
101CH2S
SA-JER-DS011-TRJR-480017
2"-CLD-011009301-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480017
2"
CLD
011
009306
101CH2S
2"-CRU-011009005-103CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
009306
101CH2S
SA-JER-DS011-TRJR-480017
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
009306
101CH2S
Insul Brk
4"-CLD-011010313-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480017
2"
CLD
011
009307
101CH2S
2"-HFO-011009004-103CL2P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480017
2"
CLD
011
009307
101CH2S
2"-CRU-011009003-103CS1P-P
2"-CLD-011009307-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
009307
101CH2S
SA-JER-DS011-TRJR-480017
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
009307
101CH2S
Insul Brk
4"-CLD-011009306-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480017
2"
CLD
011
009308
101CH2S
2"-HFO-011009005-103CL2P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
009308
101CH2S
SA-JER-DS011-TRJR-480017
2"-CLD-011009303-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480018
2"
CLD
011
010301
101CH2S
2"-DIE-011010003-103CS2P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480018
2"
CLD
011
010301
101CH2S
2"-DIE-011010006-103CS2P-P
2"-CLD-011010301-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
010301
101CH2S
SA-JER-DS011-TRJR-480018
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
010301
101CH2S
Insul Brk
4"-CLD-011009301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480019
2"
CLD
011
010302
101CH2S
2"-HFO-011010105-103CL2P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
010302
101CH2S
SA-JER-DS011-TRJR-480019
4"-CLD-011010302-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
010302
101CH2S
2"-CLD-011010302-101CH2S-P
4"-CLD-011011303-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480019
2"
CLD
011
010303
101CH2S
2"-CRU-011010007-103CS1P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
HC CLOSED DRAIN
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 22 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
3"-CLD-011003301-101CH2S-P
-
-
P
25
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
Liquid
1000
0.50
25.00
-
170.00
3.50
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
(NOTE 7)
SA-JER-DS011-TRJR-480230
2"
CLD
011
010303
101CH2S
SA-JER-DS011-TRJR-480019
SA-JER-DS011-TRJR-480018
2"
CLD
011
010304
101CH2S
2"-DIE-011010005-103CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
010304
101CH2S
SA-JER-DS011-TRJR-480018
4"-CLD-011010304-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
010304
101CH2S
2"-CLD-011010304-101CH2S-P
6"-CLD-011078318-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480018
2"
CLD
011
010305
101CH2S
2"-CRU-011010008-103CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
010305
101CH2S
SA-JER-DS011-TRJR-480018
2"-CLD-011010304-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480019
2"
CLD
011
010306
101CH2S
2"-CRU-011010009-103CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480019
2"
CLD
011
010306
101CH2S
2"-HFO-011010107-103CS1P-S
2"-CLD-011010306-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
010306
101CH2S
SA-JER-DS011-TRJR-480019
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
010306
101CH2S
Insul Brk
4"-CLD-011010311-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480019
2"
CLD
011
010308
101CH2S
2"-CRU-011010010-103CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480019
2"
CLD
011
010308
101CH2S
2"-HFO-011010108-103CS1P-S
2"-CLD-011010308-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
010308
101CH2S
SA-JER-DS011-TRJR-480019
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
010308
101CH2S
Insul Brk
4"-CLD-011010309-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480019
2"
CLD
011
010309
101CH2S
2"-HFO-011010109-103CL2P-S
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
010309
101CH2S
SA-JER-DS011-TRJR-480019
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
010309
101CH2S
Insul Brk
6"-CLD-011078318-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480019
2"
CLD
011
010310
101CH2S
2"-CRU-011010011-103CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
010310
101CH2S
SA-JER-DS011-TRJR-480019
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
010310
101CH2S
Insul Brk
4"-CLD-011010309-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480019
2"
CLD
011
010311
101CH2S
2"-HFO-011010110-103CL2P-S
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
010311
101CH2S
SA-JER-DS011-TRJR-480019
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
010311
101CH2S
Insul Brk
6"-CLD-011078318-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480019
2"
CLD
011
010313
101CH2S
2"-CRU-011010012-103CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
010313
101CH2S
SA-JER-DS011-TRJR-480019
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
010313
101CH2S
Insul Brk
4"-CLD-011010311-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480020
6"
CLD
011
011301
101CH2S
6"-CRU-011011006-106CS1P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
6"
CLD
011
011301
101CH2S
SA-JER-DS011-TRJR-480020
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
6"
CLD
011
011301
101CH2S
Insul Brk
6"-CLD-011078308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480021
2"
CLD
011
011302
101CH2S
2"-CRU-011011008-106CS1P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
011302
101CH2S
SA-JER-DS011-TRJR-480021
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
011302
101CH2S
Insul Brk
6"-CLD-011078308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480021
2"
CLD
011
011303
101CH2S
2"-CRU-011011009-106CS1P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
011303
101CH2S
SA-JER-DS011-TRJR-480021
4"-CLD-011011303-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
011303
101CH2S
2"-CLD-011011303-101CH2S-P
6"-CLD-011078308-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480021
2"
CLD
011
011304
101CH2S
2"-CRU-011011010-106CS1P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
011304
101CH2S
SA-JER-DS011-TRJR-480021
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
011304
101CH2S
Insul Brk
6"-CLD-011078308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480022
2"
CLD
011
012301
101CH2S
2"-NAP-011012007-101CH2S-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
012301
101CH2S
SA-JER-DS011-TRJR-480022
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
012301
101CH2S
Insul Brk
6"-CLD-011078308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480022
2"
CLD
011
012302
101CH2S
2"-NAP-011012008-101CH2S-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
012302
101CH2S
SA-JER-DS011-TRJR-480022
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
012302
101CH2S
Insul Brk
6"-CLD-011078308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480022
2"
CLD
011
012303
101CH2S
2"-NAP-011012009-101CH2S-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
012303
101CH2S
SA-JER-DS011-TRJR-480022
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
012303
101CH2S
Insul Brk
6"-CLD-011078308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480023
2"
CLD
011
012304
101CH2S
2"-AWS-011012004-101CH2S-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
HC CLOSED DRAIN
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 23 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
SA-JER-DS011-TRJR-480023
Insul Brk
-
-
P
25
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
(NOTE 7)
SA-JER-DS011-TRJR-480231
2"
CLD
011
012304
101CH2S
SA-JER-DS011-TRJR-480231
4"
CLD
011
012304
101CH2S
Insul Brk
4"-CLD-011003316-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480022
2"
CLD
011
012306
101CH2S
2"-NAP-011012012-103CH2S-N
SA-JER-DS011-TRJR-480231
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
012306
101CH2S
SA-JER-DS011-TRJR-480022
4"-CLD-011012306-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
012306
101CH2S
2"-CLD-011012306-101CH2S-N
6"-CLD-011078308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480023
2"
CLD
011
012307
101CH2S
2"-AWS-011012009-101CH2S-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
012307
101CH2S
SA-JER-DS011-TRJR-480023
3"-CLD-011003301-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480024
2"
CLD
011
013302
101CH2S
2"-HFO-011013011-103CL2P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
013302
101CH2S
SA-JER-DS011-TRJR-480024
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
013302
101CH2S
Insul Brk
6"-CLD-011078308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480025
2"
CLD
011
013303
101CH2S
2"-CRU-011013005-106CS1P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
013303
101CH2S
SA-JER-DS011-TRJR-480025
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
013303
101CH2S
Insul Brk
4"-CLD-011013304-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480025
2"
CLD
011
013304
101CH2S
2"-HFO-011013007-103CL2P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
013304
101CH2S
SA-JER-DS011-TRJR-480025
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
013304
101CH2S
Insul Brk
4"-CLD-011014301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480025
2"
CLD
011
013305
101CH2S
2"-CRU-011013006-106CS1P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
013305
101CH2S
SA-JER-DS011-TRJR-480025
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
013305
101CH2S
Insul Brk
4"-CLD-011014302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480025
2"
CLD
011
013306
101CH2S
2"-HFO-011013008-103CL2P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
013306
101CH2S
SA-JER-DS011-TRJR-480025
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
013306
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480141
2"
CLD
011
013307
101CH2S
2"-HFO-011013014-103CL2P-S
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
013307
101CH2S
SA-JER-DS011-TRJR-480141
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
013307
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480141
2"
CLD
011
013308
101CH2S
2"-HFO-011013013-103CL2P-S
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
013308
101CH2S
SA-JER-DS011-TRJR-480141
4"-CLD-011013308-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
013308
101CH2S
2"-CLD-011013308-101CH2S-P
6"-CLD-011078301-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480141
2"
CLD
011
013309
101CH2S
2"-HFO-011013009-103SD0P-S
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
013309
101CH2S
SA-JER-DS011-TRJR-480141
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
013309
101CH2S
Insul Brk
4"-CLD-011013308-101CH2S-P
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480141
2"
CLD
011
013310
101CH2S
2"-HFO-011013010-103SD0P-S
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
013310
101CH2S
SA-JER-DS011-TRJR-480141
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
013310
101CH2S
Insul Brk
6"-CLD-011078302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480024
2"
CLD
011
013312
101CH2S
2"-CRU-011013011-106CS1P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
013312
101CH2S
SA-JER-DS011-TRJR-480024
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
013312
101CH2S
Insul Brk
6"-CLD-011078308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480024
2"
CLD
011
013313
101CH2S
2"-HFO-011013021-103CS1P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
013313
101CH2S
SA-JER-DS011-TRJR-480024
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
013313
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480024
2"
CLD
011
013314
101CH2S
2"-CRU-011013013-106CS1P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
013314
101CH2S
SA-JER-DS011-TRJR-480024
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
013314
101CH2S
Insul Brk
6"-CLD-011078308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480024
2"
CLD
011
013315
101CH2S
2"-CRU-011013016-106CS1P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
013315
101CH2S
SA-JER-DS011-TRJR-480024
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
013315
101CH2S
Insul Brk
6"-CLD-011078308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480025
2"
CLD
011
013316
101CH2S
2"-CRU-011013017-106CS1P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
013316
101CH2S
SA-JER-DS011-TRJR-480025
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 24 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480231
4"
CLD
011
013316
101CH2S
Insul Brk
6"-CLD-011078335-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480025
2"
CLD
011
013317
101CH2S
2"-HFO-011013025-103CL2P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
013317
101CH2S
SA-JER-DS011-TRJR-480025
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
013317
101CH2S
Insul Brk
6"-CLD-011078335-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480025
2"
CLD
011
013318
101CH2S
2"-HFO-011013026-103CL2P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
013318
101CH2S
SA-JER-DS011-TRJR-480025
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
013318
101CH2S
Insul Brk
6"-CLD-011078335-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480025
2"
CLD
011
013319
101CH2S
2"-CRU-011013018-106CS1P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
013319
101CH2S
SA-JER-DS011-TRJR-480025
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
013319
101CH2S
Insul Brk
6"-CLD-011078335-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480024
2"
CLD
011
013320
101CH2S
2"-HFO-011013027-103CL2P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
013320
101CH2S
SA-JER-DS011-TRJR-480024
2"-CLD-011013315-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480026
2"
CLD
011
014301
101CH2S
2"-CRU-011014005-106CS1P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
014301
101CH2S
SA-JER-DS011-TRJR-480026
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
014301
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480026
2"
CLD
011
014302
101CH2S
2"-CRU-011014004-106CS1P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
014302
101CH2S
SA-JER-DS011-TRJR-480026
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
014302
101CH2S
Insul Brk
4"-CLD-011013306-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480026
2"
CLD
011
014303
101CH2S
2"-HFO-011014003-103CL2P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
014303
101CH2S
SA-JER-DS011-TRJR-480026
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
014303
101CH2S
Insul Brk
4"-CLD-011014307-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480026
2"
CLD
011
014304
101CH2S
2"-HFO-011014004-103CL2P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
014304
101CH2S
SA-JER-DS011-TRJR-480026
2"-CLD-011014304-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
014304
101CH2S
2"-CLD-011014304-101CH2S-P
6"-CLD-011078322-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480026
2"
CLD
011
014305
101CH2S
2"-HFO-011014005-103CL2P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
014305
101CH2S
SA-JER-DS011-TRJR-480026
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
014305
101CH2S
Insul Brk
4"-CLD-011014313-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480026
2"
CLD
011
014306
101CH2S
2"-HFO-011014006-103CL2P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
014306
101CH2S
SA-JER-DS011-TRJR-480026
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
014306
101CH2S
Insul Brk
6"-CLD-011078308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480027
2"
CLD
011
014307
101CH2S
2"-CRU-011014006-106CS1P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
014307
101CH2S
SA-JER-DS011-TRJR-480027
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
014307
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480027
2"
CLD
011
014308
101CH2S
2"-HFO-011014109-103CL2P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
014308
101CH2S
SA-JER-DS011-TRJR-480027
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
014308
101CH2S
Insul Brk
4"-CLD-011014307-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480027
2"
CLD
011
014309
101CH2S
2"-CRU-011014008-106CS1P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
014309
101CH2S
SA-JER-DS011-TRJR-480027
4"-CLD-011014309-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
014309
101CH2S
2"-CLD-011014309-101CH2S-P
6"-CLD-011078322-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480027
2"
CLD
011
014310
101CH2S
2"-HFO-011014108-103CL2P-S
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
014310
101CH2S
SA-JER-DS011-TRJR-480027
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
014310
101CH2S
Insul Brk
4"-CLD-011015305-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480027
2"
CLD
011
014311
101CH2S
2"-HFO-011014106-103CL4P-S
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
014311
101CH2S
SA-JER-DS011-TRJR-480027
4"-CLD-011014311-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
014311
101CH2S
2"-CLD-011014311-101CH2S-P
6"-CLD-011078301-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480027
2"
CLD
011
014312
101CH2S
2"-HFO-011014107-103CL2P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
014312
101CH2S
SA-JER-DS011-TRJR-480027
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
014312
101CH2S
Insul Brk
6"-CLD-011078308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 25 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
SA-JER-DS011-TRJR-480231
-
-
P
25
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
200.00
-
H
5.25
NFS
YES
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480026
2"
CLD
011
014313
101CH2S
2"-HFO-011014010-103CL2P-P
SA-JER-DS011-TRJR-480231
2"
CLD
011
014313
101CH2S
SA-JER-DS011-TRJR-480026
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480231
4"
CLD
011
014313
101CH2S
Insul Brk
6"-CLD-011078308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480026
2"
CLD
011
014314
101CH2S
2"-HFO-011014011-103CL2P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480231
2"
CLD
011
014314
101CH2S
SA-JER-DS011-TRJR-480026
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480231
4"
CLD
011
014314
101CH2S
Insul Brk
6"-CLD-011078335-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
SA-JER-DS011-TRJR-480026
2"
CLD
011
014315
101CH2S
2"-HFO-011014012-103CL2P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480231
2"
CLD
011
014315
101CH2S
SA-JER-DS011-TRJR-480026
2"-CLD-011014318-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
SA-JER-DS011-TRJR-480027
2"
CLD
011
014316
101CH2S
2"-CRU-011014009-106CS2P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
SA-JER-DS011-TRJR-480231
2"
CLD
011
014316
101CH2S
SA-JER-DS011-TRJR-480027
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
SA-JER-DS011-TRJR-480231
4"
CLD
011
014316
101CH2S
Insul Brk
4"-CLD-011013318-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
SA-JER-DS011-TRJR-480027
2"
CLD
011
014317
101CH2S
2"-HFO-011014112-103CL4P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
SA-JER-DS011-TRJR-480231
2"
CLD
011
014317
101CH2S
SA-JER-DS011-TRJR-480027
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480231
4"
CLD
011
014317
101CH2S
Insul Brk
4"-CLD-011020301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480027
2"
CLD
011
014318
101CH2S
2"-CRU-011014010-106CS2P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480231
2"
CLD
011
014318
101CH2S
SA-JER-DS011-TRJR-480027
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480231
4"
CLD
011
014318
101CH2S
Insul Brk
4"-CLD-011014319-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
SA-JER-DS011-TRJR-480027
2"
CLD
011
014319
101CH2S
2"-HFO-011014113-103CL4P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480231
2"
CLD
011
014319
101CH2S
SA-JER-DS011-TRJR-480027
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480231
4"
CLD
011
014319
101CH2S
Insul Brk
6"-CLD-011078335-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480027
2"
CLD
011
014320
101CH2S
2"-HFO-011014114-103CL2P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
SA-JER-DS011-TRJR-480231
2"
CLD
011
014320
101CH2S
SA-JER-DS011-TRJR-480027
2"-CLD-011013302-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
SA-JER-DS011-TRJR-480028
2"
CLD
011
015301
101CH2S
2"-CRU-011015009-106CS2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480230
2"
CLD
011
015301
101CH2S
SA-JER-DS011-TRJR-480028
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480230
4"
CLD
011
015301
101CH2S
Insul Brk
4"-CLD-011015302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
SA-JER-DS011-TRJR-480028
2"
CLD
011
015302
101CH2S
2"-HFO-011015005-103CL2P-S
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
SA-JER-DS011-TRJR-480230
2"
CLD
011
015302
101CH2S
SA-JER-DS011-TRJR-480028
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480230
4"
CLD
011
015302
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480230
4"
CLD
011
015302
101CH2S
4"-CLD-011015307-101CH2S-N
4"-CLD-011015302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480028
2"
CLD
011
015303
101CH2S
2"-CRU-011015010-106CS2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480230
2"
CLD
011
015303
101CH2S
SA-JER-DS011-TRJR-480028
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480230
4"
CLD
011
015303
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480028
2"
CLD
011
015304
101CH2S
2"-HFO-011015008-103CL2P-S
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480230
2"
CLD
011
015304
101CH2S
SA-JER-DS011-TRJR-480028
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480230
4"
CLD
011
015304
101CH2S
Insul Brk
4"-CLD-011015303-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
SA-JER-DS011-TRJR-480028
2"
CLD
011
015305
101CH2S
2"-CRU-011015012-106CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480230
2"
CLD
011
015305
101CH2S
SA-JER-DS011-TRJR-480028
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480230
4"
CLD
011
015305
101CH2S
Insul Brk
4"-CLD-011014309-101CH2S-P
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480028
2"
CLD
011
015306
101CH2S
2"-HFO-011015006-103CL2P-S
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480230
2"
CLD
011
015306
101CH2S
SA-JER-DS011-TRJR-480028
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480230
4"
CLD
011
015306
101CH2S
Insul Brk
4"-CLD-011014310-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
SA-JER-DS011-TRJR-480028
2"
CLD
011
015307
101CH2S
2"-CRU-011015011-106CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480230
2"
CLD
011
015307
101CH2S
SA-JER-DS011-TRJR-480028
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480230
4"
CLD
011
015307
101CH2S
Insul Brk
4"-CLD-011015302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480028
2"
CLD
011
015308
101CH2S
2"-HFO-011015007-103CL2P-S
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480230
2"
CLD
011
015308
101CH2S
SA-JER-DS011-TRJR-480028
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480230
4"
CLD
011
015308
101CH2S
Insul Brk
4"-CLD-011015302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
SA-JER-DS011-TRJR-480029
2"
CLD
011
015309
101CH2S
2"-CRU-011015013-106CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-380001
LETHAL
Q
Y
N
N
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
N
N
-
N
N
N
N
-
N
N
N
N
N
-
Y
N
N
N
N
N
-
Y
N
N
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
N
N
-
N
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 26 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
SA-JER-DS011-TRJR-480029
Insul Brk
-
-
P
25
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
Liquid
1000
0.50
25.00
-
170.00
3.50
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
(NOTE 7)
SA-JER-DS011-TRJR-480230
2"
CLD
011
015309
101CH2S
SA-JER-DS011-TRJR-480230
4"
CLD
011
015309
101CH2S
Insul Brk
4"-CLD-011015310-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480029
2"
CLD
011
015310
101CH2S
2"-HFO-011015105-103CL4P-S
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
015310
101CH2S
SA-JER-DS011-TRJR-480029
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
015310
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480029
2"
CLD
011
015311
101CH2S
2"-CRU-011015015-106CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
015311
101CH2S
SA-JER-DS011-TRJR-480029
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
015311
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480029
2"
CLD
011
015312
101CH2S
2"-HFO-011015107-103CL4P-S
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
015312
101CH2S
SA-JER-DS011-TRJR-480029
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
015312
101CH2S
Insul Brk
4"-CLD-011015311-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480029
2"
CLD
011
015313
101CH2S
2"-CRU-011015014-106CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
015313
101CH2S
SA-JER-DS011-TRJR-480029
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
015313
101CH2S
Insul Brk
4"-CLD-011015314-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480029
2"
CLD
011
015314
101CH2S
2"-HFO-011015108-103CL4P-S
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
015314
101CH2S
SA-JER-DS011-TRJR-480029
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
015314
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480029
2"
CLD
011
015315
101CH2S
2"-CRU-011015016-106CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
015315
101CH2S
SA-JER-DS011-TRJR-480029
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
015315
101CH2S
Insul Brk
4"-CLD-011015310-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480029
2"
CLD
011
015316
101CH2S
2"-HFO-011015106-103CL4P-S
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
015316
101CH2S
SA-JER-DS011-TRJR-480029
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
015316
101CH2S
Insul Brk
4"-CLD-011015315-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480028
2"
CLD
011
015317
101CH2S
2"-CRU-011015031-106CL2P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
015317
101CH2S
SA-JER-DS011-TRJR-480028
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
015317
101CH2S
Insul Brk
6"-CLD-011078335-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480028
2"
CLD
011
015318
101CH2S
2"-CRU-011015032-106CS2P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
015318
101CH2S
SA-JER-DS011-TRJR-480028
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
015318
101CH2S
Insul Brk
6"-CLD-011078335-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480028
2"
CLD
011
015319
101CH2S
2"-HFO-011015011-103CL2P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
015319
101CH2S
SA-JER-DS011-TRJR-480028
2"-CLD-011014319-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480028
2"
CLD
011
015320
101CH2S
2"-CRU-011015033-106CL2P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
015320
101CH2S
SA-JER-DS011-TRJR-480028
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
015320
101CH2S
Insul Brk
6"-CLD-011078335-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480028
2"
CLD
011
015321
101CH2S
2"-HFO-011015012-103CL2P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
015321
101CH2S
SA-JER-DS011-TRJR-480028
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
015321
101CH2S
Insul Brk
6"-CLD-011078335-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480028
2"
CLD
011
015322
101CH2S
2"-HFO-011015013-103CL2P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
015322
101CH2S
SA-JER-DS011-TRJR-480028
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
015322
101CH2S
Insul Brk
6"-CLD-011078335-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480029
2"
CLD
011
015323
101CH2S
2"-CRU-011015034-106CL2P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
015323
101CH2S
SA-JER-DS011-TRJR-480029
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
015323
101CH2S
Insul Brk
6"-CLD-011078335-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480029
2"
CLD
011
015324
101CH2S
2"-CRU-011015035-106CL2P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
015324
101CH2S
SA-JER-DS011-TRJR-480029
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
015324
101CH2S
Insul Brk
6"-CLD-011078335-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480029
2"
CLD
011
015325
101CH2S
2"-HFO-011015111-103CL4P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
015325
101CH2S
SA-JER-DS011-TRJR-480029
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
HC CLOSED DRAIN
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 27 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480231
4"
CLD
011
015325
101CH2S
Insul Brk
6"-CLD-011078335-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480029
2"
CLD
011
015326
101CH2S
2"-HFO-011015113-103CL4P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
015326
101CH2S
SA-JER-DS011-TRJR-480029
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
015326
101CH2S
Insul Brk
6"-CLD-011078335-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480029
2"
CLD
011
015327
101CH2S
2"-CRU-011015036-106CL2P-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
015327
101CH2S
SA-JER-DS011-TRJR-480029
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
015327
101CH2S
Insul Brk
6"-CLD-011078335-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480029
2"
CLD
011
015328
101CH2S
2"-HFO-011015112-103CL4P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
015328
101CH2S
SA-JER-DS011-TRJR-480029
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
015328
101CH2S
Insul Brk
6"-CLD-011078335-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480030
2"
CLD
011
016301
101CH2S
2"-CRU-011016002-106CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
016301
101CH2S
SA-JER-DS011-TRJR-480030
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
016301
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
016301
101CH2S
4"-CLD-011016304-101CH2S-N
4"-CLD-011016301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480030
2"
CLD
011
016302
101CH2S
2"-CRU-011016003-106CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
016302
101CH2S
SA-JER-DS011-TRJR-480030
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
016302
101CH2S
Insul Brk
4"-CLD-011016301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480031
2"
CLD
011
016303
101CH2S
2"-CRU-011016004-106CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
016303
101CH2S
SA-JER-DS011-TRJR-480031
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
016303
101CH2S
Insul Brk
4"-CLD-011016304-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480031
2"
CLD
011
016304
101CH2S
2"-CRU-011016005-106CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
016304
101CH2S
SA-JER-DS011-TRJR-480031
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
016304
101CH2S
Insul Brk
4"-CLD-011016301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480032
2"
CLD
011
016305
101CH2S
2"-CRU-011016006-106CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
016305
101CH2S
SA-JER-DS011-TRJR-480032
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
016305
101CH2S
Insul Brk
4"-CLD-011016306-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480032
2"
CLD
011
016306
101CH2S
2"-CRU-011016007-106CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
016306
101CH2S
SA-JER-DS011-TRJR-480032
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
016306
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480033
2"
CLD
011
016307
101CH2S
2"-CRU-011016008-106CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
016307
101CH2S
SA-JER-DS011-TRJR-480033
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
016307
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480033
2"
CLD
011
016308
101CH2S
2"-CRU-011016009-106CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
016308
101CH2S
SA-JER-DS011-TRJR-480033
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
016308
101CH2S
Insul Brk
4"-CLD-011016307-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480034
2"
CLD
011
017301
101CH2S
2"-CRU-011017010-101CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
017301
101CH2S
SA-JER-DS011-TRJR-480034
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
017301
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480035
2"
CLD
011
017302
101CH2S
2"-CRU-011017011-101CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
017302
101CH2S
SA-JER-DS011-TRJR-480035
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
017302
101CH2S
Insul Brk
4"-CLD-011017301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480036
2"
CLD
011
017303
101CH2S
2"-CRU-011017012-101CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
017303
101CH2S
SA-JER-DS011-TRJR-480036
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
017303
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480037
2"
CLD
011
017304
101CH2S
2"-CRU-011017013-101CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
017304
101CH2S
SA-JER-DS011-TRJR-480037
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
017304
101CH2S
Insul Brk
4"-CLD-011017303-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480038
2"
CLD
011
017305
101CH2S
2"-CRU-011017014-101CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 28 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
SA-JER-DS011-TRJR-480038
Insul Brk
-
-
P
25
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
Liquid
1000
0.50
25.00
-
170.00
3.50
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
(NOTE 7)
SA-JER-DS011-TRJR-480230
2"
CLD
011
017305
101CH2S
SA-JER-DS011-TRJR-480230
4"
CLD
011
017305
101CH2S
Insul Brk
4"-CLD-011017306-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480039
2"
CLD
011
017306
101CH2S
2"-CRU-011017015-101CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
017306
101CH2S
SA-JER-DS011-TRJR-480039
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
017306
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480040
2"
CLD
011
017307
101CH2S
2"-CRU-011017016-101CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
017307
101CH2S
SA-JER-DS011-TRJR-480040
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
017307
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480041
2"
CLD
011
017308
101CH2S
2"-CRU-011017017-101CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
017308
101CH2S
SA-JER-DS011-TRJR-480041
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
017308
101CH2S
Insul Brk
4"-CLD-011017307-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480043
2"
CLD
011
018301
101CH2S
2"-DIE-011018004-103CS1P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
018301
101CH2S
SA-JER-DS011-TRJR-480043
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
018301
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480044
2"
CLD
011
018303
101CH2S
2"-DIE-011018008-101CS2P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
018303
101CH2S
SA-JER-DS011-TRJR-480044
4"-CLD-011018315-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480044
2"
CLD
011
018304
101CH2S
2"-HFO-011018007-101CL2P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
018304
101CH2S
SA-JER-DS011-TRJR-480044
4"-CLD-011018315-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480043
2"
CLD
011
018306
101CH2S
2"-NAP-011018003-101CH2S-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
018306
101CH2S
SA-JER-DS011-TRJR-480043
2"-CLD-011018308-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480044
2"
CLD
011
018307
101CH2S
2"-CRU-011018004-101CL4P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
018307
101CH2S
SA-JER-DS011-TRJR-480044
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
018307
101CH2S
Insul Brk
6"-CLD-011078321-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480043
2"
CLD
011
018308
101CH2S
2"-JET-011018002-101CS1P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
018308
101CH2S
SA-JER-DS011-TRJR-480043
4"-CLD-011018308-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
018308
101CH2S
2"-CLD-011018308-101CH2S-P
6"-CLD-011078301-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480044
2"
CLD
011
018309
101CH2S
2"-DIE-011018005-103CS2P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
018309
101CH2S
SA-JER-DS011-TRJR-480044
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
018309
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480044
2"
CLD
011
018310
101CH2S
2"-HFO-011018003-103CL2P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
018310
101CH2S
SA-JER-DS011-TRJR-480044
4"-CLD-011018310-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
018310
101CH2S
2"-CLD-011018310-101CH2S-P
4"-CLD-011027305-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480044
2"
CLD
011
018312
101CH2S
2"-HFO-011018102-103CL4P-S
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
018312
101CH2S
SA-JER-DS011-TRJR-480044
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
018312
101CH2S
Insul Brk
4"-CLD-011018307-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480043
2"
CLD
011
018315
101CH2S
2"-JET-011018003-101CS1P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
018315
101CH2S
SA-JER-DS011-TRJR-480043
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
018315
101CH2S
Insul Brk
6"-CLD-011078321-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480046
4"
CLD
011
019301
101CH2S
4"-AWS-011019004-101CH2S-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
170.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
019301
101CH2S
SA-JER-DS011-TRJR-480046
4"-CLD-011021301-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
170.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480047
2"
CLD
011
019302
101CH2S
2"-NAP-011019016-101CH2S-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
019302
101CH2S
SA-JER-DS011-TRJR-480047
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
019302
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480047
2"
CLD
011
019303
101CH2S
2"-NAP-011019017-101CH2S-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
019303
101CH2S
SA-JER-DS011-TRJR-480047
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
019303
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480047
2"
CLD
011
019304
101CH2S
2"-NAP-011019018-101CH2S-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
019304
101CH2S
SA-JER-DS011-TRJR-480047
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
019304
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
HC CLOSED DRAIN
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 29 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
-
-
P
25
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
Liquid
1000
0.50
25.00
-
170.00
3.50
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
(NOTE 7)
SA-JER-DS011-TRJR-480045
2"
CLD
011
019306
101CH2S
2"-NAP-011019009-101CH2S-P
SA-JER-DS011-TRJR-480227
SA-JER-DS011-TRJR-480045
2"
CLD
011
019306
101CH2S
2"-NAP-011019035-101CH2S-P
2"-CLD-011019306-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
019306
101CH2S
SA-JER-DS011-TRJR-480045
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
019306
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480046
2"
CLD
011
019308
101CH2S
2"-NAP-011019023-103CH2S-N
SA-JER-DS011-TRJR-480227
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
019308
101CH2S
SA-JER-DS011-TRJR-480046
2"-CLD-011021304-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480046
2"
CLD
011
019309
101CH2S
2"-AWS-011019012-101CH2S-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
019309
101CH2S
SA-JER-DS011-TRJR-480046
3"-CLD-011002304-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480048
2"
CLD
011
020301
101CH2S
2"-NAP-011020009-101CH2S-P
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480048
2"
CLD
011
020301
101CH2S
2"-NAP-011020003-101CH2S-P
2"-CLD-011020301-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
020301
101CH2S
SA-JER-DS011-TRJR-480048
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
020301
101CH2S
Insul Brk
6"-CLD-011078335-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480048
2"
CLD
011
020301
101CH2S
2"-NAP-011020010-101CH2S-P
2"-CLD-011020301-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480050
4"
CLD
011
021301
101CH2S
4"-AWS-011021004-101CH2S-N
SA-JER-DS011-TRJR-480227
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
021301
101CH2S
SA-JER-DS011-TRJR-480050
4"-CLD-011021301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
021301
101CH2S
4"-CLD-011021301-101CH2S-N
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480051
2"
CLD
011
021302
101CH2S
2"-NAP-011021015-103CH2S-N
SA-JER-DS011-TRJR-480227
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
021302
101CH2S
SA-JER-DS011-TRJR-480051
4"-CLD-011021302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
021302
101CH2S
2"-CLD-011021302-101CH2S-N
6"-CLD-011078321-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480051
2"
CLD
011
021303
101CH2S
2"-NAP-011021016-103CH2S-N
SA-JER-DS011-TRJR-480227
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
021303
101CH2S
SA-JER-DS011-TRJR-480051
4"-CLD-011021303-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
021303
101CH2S
2"-CLD-011021303-101CH2S-N
6"-CLD-011078321-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480051
2"
CLD
011
021304
101CH2S
2"-NAP-011021011-103CH2S-N
SA-JER-DS011-TRJR-480227
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
021304
101CH2S
SA-JER-DS011-TRJR-480051
4"-CLD-011021304-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
021304
101CH2S
2"-CLD-011021304-101CH2S-N
6"-CLD-011078321-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480050
2"
CLD
011
021305
101CH2S
2"-AWS-011021009-101CH2S-N
SA-JER-DS011-TRJR-480227
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
021305
101CH2S
SA-JER-DS011-TRJR-480050
3"-CLD-011002304-101CH2S-P
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480052
2"
CLD
011
022301
101CH2S
2"-JET-011022011-103CS1P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
022301
101CH2S
SA-JER-DS011-TRJR-480052
2"-CLD-011022305-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480052
2"
CLD
011
022302
101CH2S
2"-JET-011022012-101CS1P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
022302
101CH2S
SA-JER-DS011-TRJR-480052
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
022302
101CH2S
Insul Brk
4"-CLD-011022303-101CH2S-P
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480052
4"
CLD
011
022303
101CH2S
4"-HFO-011022004-103CL2P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
022303
101CH2S
SA-JER-DS011-TRJR-480052
4"-CLD-011022303-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
022303
101CH2S
4"-CLD-011022303-101CH2S-P
6"-CLD-011078321-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480052
2"
CLD
011
022304
101CH2S
2"-HFO-011022003-103CL2P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
022304
101CH2S
SA-JER-DS011-TRJR-480052
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
022304
101CH2S
Insul Brk
4"-CLD-011022303-101CH2S-P
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480052
2"
CLD
011
022305
101CH2S
2"-JET-011022010-101CS1P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
022305
101CH2S
SA-JER-DS011-TRJR-480052
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
022305
101CH2S
Insul Brk
6"-CLD-011078321-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480052
2"
CLD
011
022306
101CH2S
2"-HFO-011022005-103CL2P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
022306
101CH2S
SA-JER-DS011-TRJR-480052
2"-CLD-011022304-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480053
2"
CLD
011
022307
101CH2S
2"-JET-011022018-103CS1P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
022307
101CH2S
SA-JER-DS011-TRJR-480053
4"-CLD-011022307-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
022307
101CH2S
2"-CLD-011022307-101CH2S-P
6"-CLD-011078321-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480053
2"
CLD
011
022308
101CH2S
2"-JET-011022019-103CS1P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
022308
101CH2S
SA-JER-DS011-TRJR-480053
4"-CLD-011022308-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
HC CLOSED DRAIN
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 30 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
-
-
P
25
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
Liquid
1000
0.50
25.00
-
170.00
3.50
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
(NOTE 7)
SA-JER-DS011-TRJR-480227
4"
CLD
011
022308
101CH2S
2"-CLD-011022308-101CH2S-P
6"-CLD-011078321-101CH2S-N
SA-JER-DS011-TRJR-480054
2"
CLD
011
023301
101CH2S
2"-DIE-011023009-101CS2P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
023301
101CH2S
SA-JER-DS011-TRJR-480054
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
023301
101CH2S
Insul Brk
4"-CLD-011018307-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480054
2"
CLD
011
023302
101CH2S
2"-DIE-011023007-101CS2P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
023302
101CH2S
SA-JER-DS011-TRJR-480054
4"-CLD-011023302-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
023302
101CH2S
2"-CLD-011023302-101CH2S-P
6"-CLD-011078321-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480055
2"
CLD
011
023303
101CH2S
2"-DIE-011023012-103CS2P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
023303
101CH2S
SA-JER-DS011-TRJR-480055
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
023303
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480055
2"
CLD
011
023304
101CH2S
2"-DIE-011023013-103CS2P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
023304
101CH2S
SA-JER-DS011-TRJR-480055
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
023304
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480056
2"
CLD
011
024301
101CH2S
2"-HFO-011024014-103CL2P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
024301
101CH2S
SA-JER-DS011-TRJR-480056
4"-CLD-011024301-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
024301
101CH2S
2"-CLD-011024301-101CH2S-P
4"-CLD-011023302-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480057
2"
CLD
011
024302
101CH2S
2"-HFO-011024008-103CL2P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
024302
101CH2S
SA-JER-DS011-TRJR-480057
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
024302
101CH2S
Insul Brk
6"-CLD-011078321-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480057
2"
CLD
011
024303
101CH2S
2"-HFO-011024009-103CL2P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
024303
101CH2S
SA-JER-DS011-TRJR-480057
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
024303
101CH2S
Insul Brk
6"-CLD-011078321-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480056
2"
CLD
011
024304
101CH2S
2"-HFO-011024016-101CL2P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
024304
101CH2S
SA-JER-DS011-TRJR-480056
2"-CLD-011023301-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480058
2"
CLD
011
025301
101CH2S
2"-JET-011025008-103CS1P-N
SA-JER-DS011-TRJR-480228
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
2"
CLD
011
025301
101CH2S
SA-JER-DS011-TRJR-480058
4"-CLD-011025301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
4"
CLD
011
025301
101CH2S
2"-CLD-011025301-101CH2S-N
4"-CLD-011025302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480058
2"
CLD
011
025302
101CH2S
2"-JET-011025003-103CS1P-P
SA-JER-DS011-TRJR-480228
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
2"
CLD
011
025302
101CH2S
SA-JER-DS011-TRJR-480058
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
M
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
4"
CLD
011
025302
101CH2S
Insul Brk
6"-CLD-011078316-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480060
2"
CLD
011
025303
101CH2S
2"-DIE-011025005-103CS1P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
025303
101CH2S
SA-JER-DS011-TRJR-480060
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
4"
CLD
011
025303
101CH2S
Insul Brk
4"-CLD-011025304-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480060
2"
CLD
011
025304
101CH2S
2"-DIE-011025011-103CS1P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
025304
101CH2S
SA-JER-DS011-TRJR-480060
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
025304
101CH2S
Insul Brk
4"-CLD-011025304-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
4"
CLD
011
025304
101CH2S
Blind flange
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480062
2"
CLD
011
025305
101CH2S
2"-HFO-011025005-103CS1P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
025305
101CH2S
SA-JER-DS011-TRJR-480062
4"-CLD-011025305-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
4"
CLD
011
025305
101CH2S
2"-CLD-011025305-101CH2S-P
6"-CLD-011078317-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480062
2"
CLD
011
025306
101CH2S
2"-HFO-011025006-103CS1P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
025306
101CH2S
SA-JER-DS011-TRJR-480062
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
4"
CLD
011
025306
101CH2S
Insul Brk
4"-CLD-011025304-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480058
2"
CLD
011
025313
101CH2S
2"-JET-011025007-103CS1P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
025313
101CH2S
SA-JER-DS011-TRJR-480058
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
4"
CLD
011
025313
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480060
2"
CLD
011
025315
101CH2S
2"-DIE-011025010-103CS1P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
025315
101CH2S
SA-JER-DS011-TRJR-480060
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
HC CLOSED DRAIN
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 31 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
-
-
N
-
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
Liquid
1000
0.50
25.00
-
170.00
3.50
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
(NOTE 7)
SA-JER-DS011-TRJR-480229
4"
CLD
011
025315
101CH2S
Insul Brk
4"-CLD-011025305-101CH2S-P
SA-JER-DS011-TRJR-480061
2"
CLD
011
025316
101CH2S
2"-HFO-011025012-103CS1P-P
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
025316
101CH2S
SA-JER-DS011-TRJR-480061
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
4"
CLD
011
025316
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480063
2"
CLD
011
026301
101CH2S
2"-JET-011026006-101CS1P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
026301
101CH2S
SA-JER-DS011-TRJR-480063
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
026301
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480063
2"
CLD
011
026302
101CH2S
2"-JET-011026007-101CS1P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
026302
101CH2S
SA-JER-DS011-TRJR-480063
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
026302
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480064
2"
CLD
011
026303
101CH2S
2"-DIE-011026006-103CS2P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
026303
101CH2S
SA-JER-DS011-TRJR-480064
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
026303
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480064
2"
CLD
011
026304
101CH2S
2"-DIE-011026007-103CS2P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
026304
101CH2S
SA-JER-DS011-TRJR-480064
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
026304
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480065
2"
CLD
011
027301
101CH2S
2"-HFO-011027006-103CL2P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
027301
101CH2S
SA-JER-DS011-TRJR-480065
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
027301
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480065
2"
CLD
011
027302
101CH2S
2"-HFO-011027007-103CL2P-P
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
027302
101CH2S
SA-JER-DS011-TRJR-480065
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
027302
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480066
2"
CLD
011
027303
101CH2S
2"-HFO-011027107-103CL4P-S
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
027303
101CH2S
SA-JER-DS011-TRJR-480066
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
027303
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480066
2"
CLD
011
027304
101CH2S
2"-HFO-011027108-103CL4P-S
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
027304
101CH2S
SA-JER-DS011-TRJR-480066
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
027304
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480066
2"
CLD
011
027305
101CH2S
2"-HFO-011027112-103CL4P-S
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
027305
101CH2S
SA-JER-DS011-TRJR-480066
4"-CLD-011027305-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
027305
101CH2S
2"-CLD-011027305-101CH2S-P
4"-CLD-011016307-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480066
4"
CLD
011
027306
101CH2S
4"-HFO-011027121-103CL4P-S
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480066
4"
CLD
011
027306
101CH2S
4"-HFO-011027122-103CL4P-S
4"-CLD-011027306-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
027306
101CH2S
SA-JER-DS011-TRJR-480066
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
027306
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480066
2"
CLD
011
027308
101CH2S
2"-HFO-011027123-103CL4P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
027308
101CH2S
SA-JER-DS011-TRJR-480066
4"-CLD-011027308-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
027308
101CH2S
2"-CLD-011027308-101CH2S-P
6"-CLD-011078335-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480066
2"
CLD
011
027309
101CH2S
2"-HFO-011027124-103CL4P-S
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
027309
101CH2S
SA-JER-DS011-TRJR-480066
4"-CLD-011027309-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
027309
101CH2S
2"-CLD-011027309-101CH2S-P
6"-CLD-011078301-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480066
2"
CLD
011
027310
101CH2S
2"-HFO-011027132-103CL4P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
027310
101CH2S
SA-JER-DS011-TRJR-480066
2"-CLD-011027308-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480067
2"
CLD
011
028301
101CH2S
2"-HFO-011028101-103CL4P-S
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
028301
101CH2S
SA-JER-DS011-TRJR-480067
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
028301
101CH2S
Insul Brk
4"-CLD-011028302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480067
2"
CLD
011
028302
101CH2S
2"-HFO-011028102-103CL4P-S
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
028302
101CH2S
SA-JER-DS011-TRJR-480067
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
HC CLOSED DRAIN
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 32 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
-
-
N
-
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
Liquid
1000
0.50
25.00
-
170.00
3.50
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
(NOTE 7)
SA-JER-DS011-TRJR-480230
4"
CLD
011
028302
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
SA-JER-DS011-TRJR-480230
4"
CLD
011
028302
101CH2S
4"-CLD-011028303-101CH2S-N
4"-CLD-011028302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480068
2"
CLD
011
028303
101CH2S
2"-HFO-011028103-103CL4P-S
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
028303
101CH2S
SA-JER-DS011-TRJR-480068
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
028303
101CH2S
Insul Brk
4"-CLD-011028302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480068
2"
CLD
011
028304
101CH2S
2"-HFO-011028104-103CL4P-S
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
028304
101CH2S
SA-JER-DS011-TRJR-480068
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
028304
101CH2S
Insul Brk
4"-CLD-011028302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480069
2"
CLD
011
028305
101CH2S
2"-HFO-011028105-103CL4P-S
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
028305
101CH2S
SA-JER-DS011-TRJR-480069
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
028305
101CH2S
Insul Brk
4"-CLD-011028306-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480069
2"
CLD
011
028306
101CH2S
2"-HFO-011028106-103CL4P-S
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
028306
101CH2S
SA-JER-DS011-TRJR-480069
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
028306
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
028306
101CH2S
4"-CLD-011028307-101CH2S-N
4"-CLD-011028306-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480070
2"
CLD
011
028307
101CH2S
2"-HFO-011028107-103CL4P-S
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
028307
101CH2S
SA-JER-DS011-TRJR-480070
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
028307
101CH2S
Insul Brk
4"-CLD-011028306-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480070
2"
CLD
011
028308
101CH2S
2"-HFO-011028108-103CL4P-S
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
028308
101CH2S
SA-JER-DS011-TRJR-480070
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
028308
101CH2S
Insul Brk
4"-CLD-011028307-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480071
2"
CLD
011
029301
101CH2S
2"-HFO-011029118-103CM4P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
029301
101CH2S
SA-JER-DS011-TRJR-480071
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
029301
101CH2S
Insul Brk
4"-CLD-011029302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480072
2"
CLD
011
029302
101CH2S
2"-HFO-011029119-103CM4P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
029302
101CH2S
SA-JER-DS011-TRJR-480072
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
029302
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480073
2"
CLD
011
029303
101CH2S
2"-HFO-011029120-103CM4P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
029303
101CH2S
SA-JER-DS011-TRJR-480073
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
029303
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480074
2"
CLD
011
029304
101CH2S
2"-HFO-011029121-103CM4P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
029304
101CH2S
SA-JER-DS011-TRJR-480074
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
029304
101CH2S
Insul Brk
Reducer
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480075
2"
CLD
011
029305
101CH2S
2"-HFO-011029122-103CM4P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
029305
101CH2S
SA-JER-DS011-TRJR-480075
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
029305
101CH2S
Insul Brk
Reducer
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480076
2"
CLD
011
029306
101CH2S
2"-HFO-011029123-103CM4P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
029306
101CH2S
SA-JER-DS011-TRJR-480076
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
029306
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480077
2"
CLD
011
029307
101CH2S
2"-HFO-011029124-103CM4P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
029307
101CH2S
SA-JER-DS011-TRJR-480077
4"-CLD-011029307-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
029307
101CH2S
2"-CLD-011029307-101CH2S-P
6"-CLD-011078322-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480078
2"
CLD
011
029308
101CH2S
2"-HFO-011029125-103CM4P-P
SA-JER-DS011-TRJR-480230
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
029308
101CH2S
SA-JER-DS011-TRJR-480078
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
4"
CLD
011
029308
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480080
2"
CLD
011
030301
101CH2S
2"-DIE-011030005-101CS1P-S
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
030301
101CH2S
SA-JER-DS011-TRJR-480080
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
030301
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
HC CLOSED DRAIN
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 33 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
2"-HFO-011030004-101CL2P-S
SA-JER-DS011-TRJR-480226
-
-
P
25
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
(NOTE 7)
SA-JER-DS011-TRJR-480080
2"
CLD
011
030302
101CH2S
SA-JER-DS011-TRJR-480226
2"
CLD
011
030302
101CH2S
SA-JER-DS011-TRJR-480080
2"-CLD-011030301-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480081
2"
CLD
011
030303
101CH2S
2"-HFO-011030107-101SD0P-S
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
030303
101CH2S
SA-JER-DS011-TRJR-480081
4"-CLD-011030304-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480081
4"
CLD
011
030304
101CH2S
4"-HFO-011030103-101CL4P-S
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
030304
101CH2S
SA-JER-DS011-TRJR-480081
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
030304
101CH2S
Insul Brk
4"-CLD-011030301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480080
2"
CLD
011
030305
101CH2S
2"-DIE-011030003-103CS1P-P
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
60.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
030305
101CH2S
SA-JER-DS011-TRJR-480080
4"-CLD-011030305-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
60.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
030305
101CH2S
2"-CLD-011030305-101CH2S-N
4"-CLD-011037303-101CH2S-P
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480081
2"
CLD
011
030307
101CH2S
2"-HFO-011030108-101CM2P-S
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
030307
101CH2S
SA-JER-DS011-TRJR-480081
4"-CLD-011030304-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480086
2"
CLD
011
033301
101CH2S
2"-PRO-011033010-101CH2S-N
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
033301
101CH2S
SA-JER-DS011-TRJR-480086
2"-CLD-011033302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480087
2"
CLD
011
033302
101CH2S
2"-PRO-011033011-103CH2S-N
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
033302
101CH2S
SA-JER-DS011-TRJR-480087
4"-CLD-011033302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
033302
101CH2S
2"-CLD-011033302-101CH2S-N
6"-CLD-011078302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480087
2"
CLD
011
033303
101CH2S
2"-PRO-011033015-103CH2S-N
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
033303
101CH2S
SA-JER-DS011-TRJR-480087
4"-CLD-011033303-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
033303
101CH2S
2"-CLD-011033303-101CH2S-N
4"-CLD-011033304-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480087
2"
CLD
011
033304
101CH2S
2"-PRO-011033016-103CH2S-N
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
033304
101CH2S
SA-JER-DS011-TRJR-480087
4"-CLD-011033304-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
033304
101CH2S
2"-CLD-011033304-101CH2S-N
6"-CLD-011078302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480087
2"
CLD
011
033305
101CH2S
2"-PRO-011033013-103CH2S-N
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
033305
101CH2S
SA-JER-DS011-TRJR-480087
4"-CLD-011033305-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
033305
101CH2S
2"-CLD-011033305-101CH2S-N
6"-CLD-011078302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480087
2"
CLD
011
033306
101CH2S
2"-PRO-011033014-103CH2S-N
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
033306
101CH2S
SA-JER-DS011-TRJR-480087
4"-CLD-011033306-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
033306
101CH2S
2"-CLD-011033306-101CH2S-N
6"-CLD-011078302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480086
2"
CLD
011
033307
101CH2S
2"-AWS-011033012-101CH2S-N
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
033307
101CH2S
SA-JER-DS011-TRJR-480086
4"-CLD-011033307-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
033307
101CH2S
2"-CLD-011033307-101CH2S-N
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480086
3"
CLD
011
033308
101CH2S
3"-AWS-011033013-101CH2S-N
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
3"
CLD
011
033308
101CH2S
SA-JER-DS011-TRJR-480086
4"-CLD-011033308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
033308
101CH2S
3"-CLD-011033308-101CH2S-N
6"-CLD-011078302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480088
2"
CLD
011
033309
101CH2S
2"-AWS-011033015-106CH2S-N
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480088
3/4"
CLD
011
033309
101CH2S
011-G-0019-A
2"-CLD-011033309-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
033309
101CH2S
SA-JER-DS011-TRJR-480088
4"-CLD-011033309-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
033309
101CH2S
2"-CLD-011033309-101CH2S-N
6"-CLD-011078302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480088
2"
CLD
011
033310
101CH2S
2"-AWS-011033016-106CH2S-N
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480088
3/4"
CLD
011
033310
101CH2S
011-G-0019-B
2"-CLD-011033310-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
033310
101CH2S
SA-JER-DS011-TRJR-480088
4"-CLD-011033310-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
033310
101CH2S
2"-CLD-011033310-101CH2S-N
6"-CLD-011078302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480088
2"
CLD
011
033312
101CH2S
2"-AWS-011033024-106CH2S-N
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
033312
101CH2S
SA-JER-DS011-TRJR-480088
3"-CLD-011033308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480089
2"
CLD
011
034301
101CH2S
2"-AWS-011034005-101CH2S-N
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
034301
101CH2S
SA-JER-DS011-TRJR-480089
2"-CLD-011033307-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
-
H
5.25
NFS
YES
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480090
2"
CLD
011
034302
101CH2S
2"-AWS-011034008-101CH2S-N
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
200.00
-0.50
200.00
120.00
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 34 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
SA-JER-DS011-TRJR-480090
4"-CLD-011034302-101CH2S-N
-
-
N
-
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
-0.50
200.00
-0.50
200.00
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
120.00
-
H
5.25
NFS
YES
A or Q
120.00
(NOTE 7)
SA-JER-DS011-TRJR-480226
2"
CLD
011
034302
101CH2S
SA-JER-DS011-TRJR-480226
4"
CLD
011
034302
101CH2S
2"-CLD-011034302-101CH2S-N
6"-CLD-011078302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
-
H
5.25
NFS
YES
SA-JER-DS011-TRJR-480090
2"
CLD
011
034303
101CH2S
2"-AWS-011034014-106CH2S-N
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
SA-JER-DS011-TRJR-480226
2"
CLD
011
034303
101CH2S
SA-JER-DS011-TRJR-480090
2"-CLD-011034302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
SA-JER-DS011-TRJR-480091
2"
CLD
011
035301
101CH2S
2"-GAS-011035007-101CH4S-P
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
SA-JER-DS011-TRJR-480226
2"
CLD
011
035301
101CH2S
SA-JER-DS011-TRJR-480091
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480226
4"
CLD
011
035301
101CH2S
Insul Brk
6"-CLD-011078302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480264
1"
CLD
011
035302
101CH2S
TP-19
Reducer
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
40.00
-
-
5.00
170.00
-
H
7.50
NFS
YES
A or Q
Y
N
N
N
SA-JER-DS011-TRJR-480264
2"
CLD
011
035302
101CH2S
Reducer
2"-CLD-011035302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
40.00
-
-
5.00
170.00
-
H
7.50
NFS
YES
A or Q
Y
N
N
N
SA-JER-DS011-TRJR-480226
2"
CLD
011
035302
101CH2S
SA-JER-DS011-TRJR-480264
2"-CLD-011035301-101CH2S-P
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
SA-JER-DS011-TRJR-480264
2"
CLD
011
035302
101CH2S
2"-CLD-011035302-101CH2S-N
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
SA-JER-DS011-TRJR-480093
2"
CLD
011
036301
101CH2S
2"-AWS-011036007-101CH4S-N
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
SA-JER-DS011-TRJR-480226
2"
CLD
011
036301
101CH2S
SA-JER-DS011-TRJR-480093
4"-CLD-011036301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
SA-JER-DS011-TRJR-480226
4"
CLD
011
036301
101CH2S
2"-CLD-011036301-101CH2S-N
6"-CLD-011078302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
SA-JER-DS011-TRJR-480093
2"
CLD
011
036302
101CH2S
2"-AWS-011036003-101CH4S-N
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
41.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
SA-JER-DS011-TRJR-480226
2"
CLD
011
036302
101CH2S
SA-JER-DS011-TRJR-480093
2"-CLD-011036301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
41.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
SA-JER-DS011-TRJR-480098
2"
CLD
011
037004
101CH2S
2"-DIE-011037017-103CS1P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
SA-JER-DS011-TRJR-480229
2"
CLD
011
037004
101CH2S
SA-JER-DS011-TRJR-480098
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
SA-JER-DS011-TRJR-480229
4"
CLD
011
037004
101CH2S
Insul Brk
4"-CLD-011001307-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
SA-JER-DS011-TRJR-480096
2"
CLD
011
037301
101CH2S
2"-DIE-011037011-103CS1P-P
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
SA-JER-DS011-TRJR-480226
2"
CLD
011
037301
101CH2S
SA-JER-DS011-TRJR-480096
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480226
4"
CLD
011
037301
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480096
2"
CLD
011
037302
101CH2S
2"-DIE-011037012-103CS1P-P
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480226
2"
CLD
011
037302
101CH2S
SA-JER-DS011-TRJR-480096
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480226
4"
CLD
011
037302
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
SA-JER-DS011-TRJR-480096
2"
CLD
011
037303
101CH2S
2"-DIE-011037013-103CS1P-P
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
SA-JER-DS011-TRJR-480226
2"
CLD
011
037303
101CH2S
SA-JER-DS011-TRJR-480096
4"-CLD-011037303-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
SA-JER-DS011-TRJR-480226
4"
CLD
011
037303
101CH2S
2"-CLD-011037303-101CH2S-P
4"-CLD-011039301-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
SA-JER-DS011-TRJR-480097
2"
CLD
011
037308
101CH2S
2"-DIE-011037023-103CS1P-N
SA-JER-DS011-TRJR-480228
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
SA-JER-DS011-TRJR-480228
2"
CLD
011
037308
101CH2S
SA-JER-DS011-TRJR-480097
4"-CLD-011037308-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
SA-JER-DS011-TRJR-480228
4"
CLD
011
037308
101CH2S
2"-CLD-011037308-101CH2S-P
6"-CLD-011078316-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
SA-JER-DS011-TRJR-480098
2"
CLD
011
037309
101CH2S
2"-DIE-011037020-103CS1P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
SA-JER-DS011-TRJR-480229
2"
CLD
011
037309
101CH2S
SA-JER-DS011-TRJR-480098
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
037309
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480099
2"
CLD
011
038301
101CH2S
2"-HFO-011038012-103CL2P-S
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480226
2"
CLD
011
038301
101CH2S
SA-JER-DS011-TRJR-480099
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480226
4"
CLD
011
038301
101CH2S
Insul Brk
6"-CLD-011078302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
SA-JER-DS011-TRJR-480099
2"
CLD
011
038302
101CH2S
2"-HFO-011038013-103CL2P-S
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480226
2"
CLD
011
038302
101CH2S
SA-JER-DS011-TRJR-480099
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480226
4"
CLD
011
038302
101CH2S
Insul Brk
6"-CLD-011078302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480099
2"
CLD
011
038303
101CH2S
2"-HFO-011038014-103CL2P-S
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480226
2"
CLD
011
038303
101CH2S
SA-JER-DS011-TRJR-480099
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480226
4"
CLD
011
038303
101CH2S
Insul Brk
6"-CLD-011078302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
SA-JER-DS011-TRJR-480100
2"
CLD
011
038304
101CH2S
2"-HFO-011038016-103CS1P-S
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480104
2"
CLD
011
038304
101CH2S
2"-HFO-011040109-103CS1P-S
SA-JER-DS011-TRJR-480100
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
SA-JER-DS011-TRJR-480216
2"
CLD
011
038304
101CH2S
SA-JER-DS011-TRJR-480100
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
SA-JER-DS011-TRJR-480216
4"
CLD
011
038304
101CH2S
Insul Brk
6"-CLD-011078318-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
SA-JER-DS011-TRJR-480100
2"
CLD
011
038304
101CH2S
SA-JER-DS011-TRJR-480104
2"-CLD-011038304-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
SA-JER-DS011-TRJR-380001
LETHAL
Y
N
N
N
N
N
-
B or Q
Y
N
N
N
N
N
-
A or Q
N
N
N
N
N
N
-
YES
A or Q
N
N
N
N
N
N
-
YES
Q
Y
N
N
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
N
-
N
N
N
N
-
N
N
N
N
N
-
N
N
N
N
N
-
Y
N
N
N
N
N
-
Y
N
N
N
N
N
-
Q
Y
N
N
N
N
N
-
Q
Y
N
N
N
N
N
-
YES
B or Q
Y
N
N
N
N
N
-
YES
Q
Y
N
N
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
N
N
-
N
N
N
N
-
N
N
N
N
N
-
N
N
N
N
N
-
N
N
N
N
N
N
-
Y
N
N
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
N
N
-
N
N
N
N
-
N
N
N
N
N
-
N
N
N
N
N
-
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 35 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
SA-JER-DS011-TRJR-480216
-
-
P
25
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
Liquid
1000
0.50
25.00
-
170.00
3.50
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
(NOTE 7)
SA-JER-DS011-TRJR-480100
2"
CLD
011
038307
101CH2S
2"-HFO-011038015-103CS1P-S
SA-JER-DS011-TRJR-480100
2"
CLD
011
038307
101CH2S
2"-HFO-011038022-103CS1P-S
2"-CLD-011038307-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
038307
101CH2S
SA-JER-DS011-TRJR-480100
4"-CLD-011038307-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
038307
101CH2S
2"-CLD-011038307-101CH2S-P
4"-CLD-011008306-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480100
2"
CLD
011
038309
101CH2S
2"-HFO-011038024-103CS1P-S
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
038309
101CH2S
SA-JER-DS011-TRJR-480100
2"-CLD-011038307-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480101
2"
CLD
011
039301
101CH2S
2"-HFO-011039011-103CL2P-S
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
039301
101CH2S
SA-JER-DS011-TRJR-480101
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
039301
101CH2S
Insul Brk
Reducer
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
6"
CLD
011
039301
101CH2S
Reducer
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480101
2"
CLD
011
039302
101CH2S
2"-HFO-011039012-103CL2P-S
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
039302
101CH2S
SA-JER-DS011-TRJR-480101
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
039302
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480102
2"
CLD
011
039303
101CH2S
2"-HFO-011039017-103CL2P-S
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
039303
101CH2S
SA-JER-DS011-TRJR-480102
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
039303
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480102
2"
CLD
011
039304
101CH2S
2"-HFO-011039015-103SD0P-S
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
039304
101CH2S
SA-JER-DS011-TRJR-480102
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
039304
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480102
2"
CLD
011
039305
101CH2S
2"-HFO-011039016-103CL2P-S
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
039305
101CH2S
SA-JER-DS011-TRJR-480102
2"-CLD-011039303-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480103
2"
CLD
011
039306
101CH2S
2"-HFO-011039107-103CL4P-S
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
039306
101CH2S
SA-JER-DS011-TRJR-480103
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
039306
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480103
2"
CLD
011
039307
101CH2S
2"-HFO-011039108-103CL4P-S
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
039307
101CH2S
SA-JER-DS011-TRJR-480103
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
039307
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480103
2"
CLD
011
039308
101CH2S
2"-HFO-011039111-103CL4P-S
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
039308
101CH2S
SA-JER-DS011-TRJR-480103
2"-CLD-011039306-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480104
2"
CLD
011
040301
101CH2S
2"-HFO-011040108-103CS1P-S
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
040301
101CH2S
SA-JER-DS011-TRJR-480104
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
040301
101CH2S
Insul Brk
6"-CLD-011078318-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480104
2"
CLD
011
040302
101CH2S
2"-HFO-011040110-103CS1P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
040302
101CH2S
SA-JER-DS011-TRJR-480104
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
040302
101CH2S
Insul Brk
6"-CLD-011078308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480104
2"
CLD
011
040307
101CH2S
2"-HFO-011040111-103CS1P-S
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
040307
101CH2S
SA-JER-DS011-TRJR-480104
2"-CLD-011040308-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480104
2"
CLD
011
040308
101CH2S
2"-HFO-011040112-103CS1P-S
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
040308
101CH2S
SA-JER-DS011-TRJR-480104
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
040308
101CH2S
Insul Brk
6"-CLD-011078318-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480104
2"
CLD
011
040310
101CH2S
2"-HFO-011040115-103CS1P-S
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
040310
101CH2S
SA-JER-DS011-TRJR-480104
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
040310
101CH2S
Insul Brk
6"-CLD-011078318-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480104
2"
CLD
011
040311
101CH2S
2"-HFO-011040121-103CS1P-S
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
040311
101CH2S
SA-JER-DS011-TRJR-480104
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
040311
101CH2S
Insul Brk
4"-CLD-011008306-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480104
2"
CLD
011
040312
101CH2S
2"-HFO-011040122-103CS1P-S
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
040312
101CH2S
SA-JER-DS011-TRJR-480104
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
HC CLOSED DRAIN
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 36 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
-
-
N
-
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
Liquid
1000
0.50
25.00
-
170.00
3.50
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
(NOTE 7)
SA-JER-DS011-TRJR-480216
4"
CLD
011
040312
101CH2S
Insul Brk
4"-CLD-011038304-101CH2S-N
SA-JER-DS011-TRJR-480104
2"
CLD
011
040313
101CH2S
2"-HFO-011040123-103CS1P-S
SA-JER-DS011-TRJR-480231
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
040313
101CH2S
SA-JER-DS011-TRJR-480104
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
040313
101CH2S
Insul Brk
4"-CLD-011040302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480109
2"
CLD
011
042301
101CH2S
2"-BRN-011042006-101CS4P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
042301
101CH2S
SA-JER-DS011-TRJR-480109
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
4"
CLD
011
042301
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480107
2"
CLD
011
042302
101CH2S
2"-BRN-011042007-103CS4P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
042302
101CH2S
SA-JER-DS011-TRJR-480107
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
042302
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480108
2"
CLD
011
042303
101CH2S
2"-BRN-011042008-101CS4P-P
SA-JER-DS011-TRJR-480229
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
042303
101CH2S
SA-JER-DS011-TRJR-480108
2"-CLD-011025316-101CH2S-P
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480110
2"
CLD
011
043301
101CH2S
2"-DIE-011043002-103CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
043301
101CH2S
SA-JER-DS011-TRJR-480110
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
043301
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480114
2"
CLD
011
044302
101CH2S
2"-AWS-011044008-106CH2S-P
SA-JER-DS011-TRJR-480227
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
62.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480114
2"
CLD
011
044302
101CH2S
011-G-0006-A
2"-CLD-011044302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
62.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
044302
101CH2S
SA-JER-DS011-TRJR-480114
4"-CLD-011044302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
62.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
044302
101CH2S
2"-CLD-011044302-101CH2S-N
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480114
2"
CLD
011
044303
101CH2S
2"-AWS-011044009-106CH2S-P
SA-JER-DS011-TRJR-480227
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
62.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480114
2"
CLD
011
044303
101CH2S
011-G-0006-B
2"-CLD-011044303-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
62.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
044303
101CH2S
SA-JER-DS011-TRJR-480114
4"-CLD-011044303-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
62.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
044303
101CH2S
2"-CLD-011044303-101CH2S-N
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480114
2"
CLD
011
044304
101CH2S
2"-AWS-011044016-106CH2S-P
SA-JER-DS011-TRJR-480227
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
62.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
044304
101CH2S
SA-JER-DS011-TRJR-480114
4"-CLD-011044304-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
62.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
044304
101CH2S
2"-CLD-011044304-101CH2S-N
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480219
2"
CLD
011
076301
101CH2S
2"-SLP-011076009-101CH2S-P
SA-JER-DS011-TRJR-480228
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
2"
CLD
011
076301
101CH2S
SA-JER-DS011-TRJR-480219
2"-CLD-011076303-101CS2P-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480219
2"
CLD
011
076302
101CS2P
2"-SLP-011076007-103CH2S-P
SA-JER-DS011-TRJR-480228
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
By Code
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
2"
CLD
011
076302
101CS2P
SA-JER-DS011-TRJR-480219
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
By Code
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
4"
CLD
011
076302
101CS2P
Insul Brk
6"-CLD-011078316-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
By Code
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480219
2"
CLD
011
076303
101CS2P
2"-SLP-011076008-103CH2S-P
SA-JER-DS011-TRJR-480228
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
By Code
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
2"
CLD
011
076303
101CS2P
SA-JER-DS011-TRJR-480219
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
By Code
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
4"
CLD
011
076303
101CS2P
Insul Brk
6"-CLD-011078316-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
By Code
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480225
2"
CLD
011
077301
101CH2S
2"-FLO-011077001-101CS1P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
077301
101CH2S
SA-JER-DS011-TRJR-480225
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
077301
101CH2S
Insul Brk
4"-CLD-011098310-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
6"
CLD
011
078301
101CH2S
Flange
SA-JER-DS011-TRJR-480227
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
6"
CLD
011
078301
101CH2S
Blind flange
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
6"
CLD
011
078301
101CH2S
SA-JER-DS011-TRJR-480226
SA-JER-DS011-TRJR-480228
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
6"
CLD
011
078301
101CH2S
Flange
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
6"
CLD
011
078301
101CH2S
SA-JER-DS011-TRJR-480227
SA-JER-DS011-TRJR-480231
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
6"
CLD
011
078301
101CH2S
SA-JER-DS011-TRJR-480228
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
6"
CLD
011
078301
101CH2S
6"-CLD-011078308-101CH2S-N
SA-JER-DS011-TRJR-480232
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480232
6"
CLD
011
078301
101CH2S
SA-JER-DS011-TRJR-480231
011-D-0014
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
6"
CLD
011
078302
101CH2S
HEADER
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
6"
CLD
011
078308
101CH2S
HEADER
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
6"
CLD
011
078316
101CH2S
HEADER
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
HC CLOSED DRAIN
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 37 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
Blind flange
SA-JER-DS011-TRJR-480216
-
-
N
-
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
(NOTE 7)
SA-JER-DS011-TRJR-480229
6"
CLD
011
078317
101CH2S
SA-JER-DS011-TRJR-480229
6"
CLD
011
078317
101CH2S
Blind flange
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
6"
CLD
011
078317
101CH2S
SA-JER-DS011-TRJR-480229
SA-JER-DS011-TRJR-480231
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
6"
CLD
011
078317
101CH2S
SA-JER-DS011-TRJR-480216
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
6"
CLD
011
078317
101CH2S
HEADER
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
6"
CLD
011
078318
101CH2S
HEADER
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
6"
CLD
011
078321
101CH2S
Flange
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
6"
CLD
011
078322
101CH2S
HEADER
SA-JER-DS011-TRJR-480231
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
6"
CLD
011
078322
101CH2S
Reducer
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
6"
CLD
011
078322
101CH2S
SA-JER-DS011-TRJR-480230
6"-CLD-011078308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
6"
CLD
011
078322
101CH2S
Reducer
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
078324
101CH2S
2"-FLO-011078308-101CS1P-N
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
3/4"
CLD
011
078324
101CH2S
2"-CLD-011078324-101CH2S-P
Blind flange
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
078324
101CH2S
Insul Brk
6"-CLD-011078308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
2"
CLD
011
078327
101CH2S
2"-FLO-011078301-101CS1P-N
2"-CLD-011078327-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
2"
CLD
011
078327
101CH2S
2"-CLD-011078327-101CH2S-N
6"-CLD-011078316-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
078328
101CH2S
2"-FLO-011078304-101CS1P-N
2"-CLD-011078328-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
078328
101CH2S
2"-CLD-011078328-101CH2S-N
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
078329
101CH2S
2"-FLO-011078305-101CS1P-N
2"-CLD-011078329-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
078329
101CH2S
2"-CLD-011078329-101CH2S-N
6"-CLD-011078302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
078330
101CH2S
2"-FLO-011078306-101CS1P-N
2"-CLD-011078330-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
078330
101CH2S
2"-CLD-011078330-101CH2S-N
6"-CLD-011078321-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480232
2"
CLD
011
078334
101CH2S
UC
011-D-0014
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
170.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480232
3/4"
CLD
011
078334
101CH2S
2"-CLD-011078334-101CH2S-P
Plug
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
170.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
6"
CLD
011
078335
101CH2S
HEADER
6"-CLD-011078308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
078336
101CH2S
2"-FLO-011078309-101CS1P-N
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
3/4"
CLD
011
078336
101CH2S
Blind flange
2"-CLD-011078336-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
078336
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
078337
101CH2S
2"-FLO-011078310-101CS1P-N
2"-CLD-011078337-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
078337
101CH2S
2"-CLD-011078337-101CH2S-N
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
078338
101CH2S
2"-FLO-011078311-101CS1P-N
2"-CLD-011078338-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
078338
101CH2S
2"-CLD-011078338-101CH2S-N
4"-CLD-011025304-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
078339
101CH2S
2"-FLO-011078312-101CS1P-N
2"-CLD-011078339-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
078339
101CH2S
2"-CLD-011078339-101CH2S-N
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
078340
101CH2S
2"-FLO-011078315-101CS1P-N
2"-CLD-011078340-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
078340
101CH2S
2"-CLD-011078340-101CH2S-N
6"-CLD-011078318-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
078341
101CH2S
2"-FLO-011078302-101CS1P-N
2"-CLD-011078341-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
078341
101CH2S
2"-CLD-011078341-101CH2S-N
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
078342
101CH2S
2"-FLO-011078317-101CS1P-N
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
3/4"
CLD
011
078342
101CH2S
2"-CLD-011078342-101CH2S-P
Blind flange
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480230
2"
CLD
011
078342
101CH2S
Insul Brk
6"-CLD-011078322-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
078345
101CH2S
2"-FLO-011078319-101CS1P-N
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
15.30
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
3/4"
CLD
011
078345
101CH2S
2"-CLD-011078345-101CH2S-P
Blind flange
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
15.30
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
078345
101CH2S
Insul Brk
6"-CLD-011078335-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
078346
101CH2S
2"-FLO-011078320-101CS1P-N
2"-CLD-011200316-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
3/4"
CLD
011
078346
101CH2S
2"-CLD-011078346-101CH2S-P
Blind flange
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
4"
CLD
011
098301
101CH2S
Blind flange
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. ALTERNATE DESIGN CONDITIONS FV @ 290ºC. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. ALTERNATE DESIGN CONDITIONS FV @ 290ºC. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 38 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
SA-JER-DS011-TRJR-480229
-
-
P
25
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
200.00
-
H
5.25
NFS
YES
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480132
2"
CLD
011
098302
101CH2S
2"-HFO-011098008-103CS1P-N
SA-JER-DS011-TRJR-480229
2"
CLD
011
098302
101CH2S
SA-JER-DS011-TRJR-480132
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
098302
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480134
2"
CLD
011
098304
101CH2S
2"-HFO-011098009-103CL2P-P
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480226
2"
CLD
011
098304
101CH2S
SA-JER-DS011-TRJR-480134
4"-CLD-011098305-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480134
2"
CLD
011
098305
101CH2S
2"-HFO-011098010-103CL2P-P
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480226
2"
CLD
011
098305
101CH2S
SA-JER-DS011-TRJR-480134
Reducer
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480226
4"
CLD
011
098305
101CH2S
Reducer
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480226
4"
CLD
011
098305
101CH2S
Insul Brk
6"-CLD-011078301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480133
2"
CLD
011
098306
101CH2S
2"-DIE-011098005-103CS1P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
098306
101CH2S
SA-JER-DS011-TRJR-480133
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
098306
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480133
2"
CLD
011
098307
101CH2S
2"-DIE-011098004-103CS1P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
098307
101CH2S
SA-JER-DS011-TRJR-480133
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
098307
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
SA-JER-DS011-TRJR-480140
2"
CLD
011
098308
101CH2S
2"-DIE-011098007-103CS1P-P
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480226
2"
CLD
011
098308
101CH2S
SA-JER-DS011-TRJR-480140
4"-CLD-011098305-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
SA-JER-DS011-TRJR-480140
2"
CLD
011
098309
101CH2S
2"-DIE-011098012-103CS1P-P
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
SA-JER-DS011-TRJR-480226
2"
CLD
011
098309
101CH2S
SA-JER-DS011-TRJR-480140
4"-CLD-011098305-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
SA-JER-DS011-TRJR-480135
2"
CLD
011
098310
101CH2S
2"-JET-011098002-103CS1P-P
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
SA-JER-DS011-TRJR-480229
2"
CLD
011
098310
101CH2S
SA-JER-DS011-TRJR-480135
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
098310
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480133
2"
CLD
011
098311
101CH2S
2"-JET-011098003-103CS1P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
098311
101CH2S
SA-JER-DS011-TRJR-480133
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
098311
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
SA-JER-DS011-TRJR-480140
2"
CLD
011
098312
101CH2S
2"-NAP-011098004-103CH2S-N
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
SA-JER-DS011-TRJR-480226
2"
CLD
011
098312
101CH2S
SA-JER-DS011-TRJR-480140
4"-CLD-011098305-101CH2S-P
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
SA-JER-DS011-TRJR-480135
2"
CLD
011
098313
101CH2S
2"-NAP-011098007-103CH2S-P
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
098313
101CH2S
SA-JER-DS011-TRJR-480135
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
098313
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480133
2"
CLD
011
098314
101CH2S
2"-CRU-011098003-103CS1P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
098314
101CH2S
SA-JER-DS011-TRJR-480133
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
098314
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
SA-JER-DS011-TRJR-480136
2"
CLD
011
098315
101CH2S
2"-SLP-011098005-103CS1P-S
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
098315
101CH2S
SA-JER-DS011-TRJR-480136
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
098315
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480134
2"
CLD
011
098316
101CH2S
2"-SLP-011098004-103CS1P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
098316
101CH2S
SA-JER-DS011-TRJR-480134
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
098316
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
SA-JER-DS011-TRJR-480132
2"
CLD
011
098317
101CH2S
2"-DIE-011098003-103CS1P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
098317
101CH2S
SA-JER-DS011-TRJR-480132
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
098317
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480132
2"
CLD
011
098319
101CH2S
2"-HFO-011098007-103CS1P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
098319
101CH2S
SA-JER-DS011-TRJR-480132
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
098319
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
SA-JER-DS011-TRJR-480136
2"
CLD
011
098320
101CH2S
2"-SLP-011098011-103CS1P-S
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
098320
101CH2S
SA-JER-DS011-TRJR-480136
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
098320
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-380001
BENCENE
Q
Y
N
N
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
-
N
N
-
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
N
N
-
N
N
N
N
-
N
N
N
N
N
-
N
N
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
N
N
-
N
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
-
N
N
-
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 39 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
SA-JER-DS011-TRJR-480230
-
-
P
25
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
200.00
-
H
5.25
NFS
YES
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480134
2"
CLD
011
098321
101CH2S
2"-HFO-011098013-103CL2P-P
SA-JER-DS011-TRJR-480230
2"
CLD
011
098321
101CH2S
SA-JER-DS011-TRJR-480134
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480230
4"
CLD
011
098321
101CH2S
Insul Brk
4"-CLD-011028302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480140
2"
CLD
011
098322
101CH2S
2"-DIE-011098011-103CS1P-P
SA-JER-DS011-TRJR-480226
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480226
2"
CLD
011
098322
101CH2S
SA-JER-DS011-TRJR-480140
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480226
4"
CLD
011
098322
101CH2S
Insul Brk
4"-CLD-011098305-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
SA-JER-DS011-TRJR-480136
2"
CLD
011
098323
101CH2S
2"-SLP-011098013-103CS1P-S
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
098323
101CH2S
SA-JER-DS011-TRJR-480136
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
098323
101CH2S
Insul Brk
4"-CLD-011098320-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480132
2"
CLD
011
098324
101CH2S
2"-HFO-011098015-103CS1P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
098324
101CH2S
SA-JER-DS011-TRJR-480132
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
098324
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480136
2"
CLD
011
098325
101CH2S
2"-SLP-011098018-103CS1P-S
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
155.00
-
H
5.25
NFS
YES
M
N
N
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
098325
101CH2S
SA-JER-DS011-TRJR-480136
4"-CLD-011098325-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
155.00
-
H
5.25
NFS
YES
M
N
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
098325
101CH2S
2"-CLD-011098325-101CH2S-P
6"-CLD-011078317-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
155.00
-
H
5.25
NFS
YES
M
N
N
N
SA-JER-DS011-TRJR-480132
2"
CLD
011
098326
101CH2S
2"-AWS-011098001-106CH2S-P
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
098326
101CH2S
SA-JER-DS011-TRJR-480132
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
098326
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480137
2"
CLD
011
099301
101CH2S
2"-HFO-011099101-103CS1P-S
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
099301
101CH2S
SA-JER-DS011-TRJR-480137
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
099301
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
SA-JER-DS011-TRJR-480138
2"
CLD
011
099302
101CH2S
2"-HFO-011099102-103CS1P-S
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
099302
101CH2S
SA-JER-DS011-TRJR-480138
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
099302
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480137
2"
CLD
011
099303
101CH2S
2"-HFO-011099001-103CS1P-S
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
099303
101CH2S
SA-JER-DS011-TRJR-480137
4"-CLD-011099303-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
099303
101CH2S
2"-CLD-011099303-101CH2S-P
6"-CLD-011078317-101CH2S-N
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480138
2"
CLD
011
099304
101CH2S
2"-HFO-011099002-103CS1P-S
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
099304
101CH2S
SA-JER-DS011-TRJR-480138
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
099304
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480274
2"
CLD
011
200301
101CH2S
2"-DIE-011200001-103CS1P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
M
Y
N
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
200301
101CH2S
SA-JER-DS011-TRJR-480274
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
M
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
200301
101CH2S
Insul Brk
4"-CLD-011025306-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
SA-JER-DS011-TRJR-480274
2"
CLD
011
200302
101CH2S
2"-DIE-011200002-103CS1P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
M
Y
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
200302
101CH2S
SA-JER-DS011-TRJR-480274
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
M
Y
N
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
200302
101CH2S
Insul Brk
4"-CLD-011025304-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480275
2"
CLD
011
200303
101CH2S
2"-CWS-011044011-106CH2S-P
SA-JER-DS011-TRJR-480227
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
62.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
SA-JER-DS011-TRJR-480227
2"
CLD
011
200303
101CH2S
SA-JER-DS011-TRJR-480275
4"-CLD-011200303-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
62.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
SA-JER-DS011-TRJR-480227
4"
CLD
011
200303
101CH2S
2"-CLD-011200303-101CH2S-N
4"-CLD-011021301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
SA-JER-DS011-TRJR-480275
2"
CLD
011
200305
101CH2S
2"-NAP-011021014-103CH2S-N
SA-JER-DS011-TRJR-480227
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
SA-JER-DS011-TRJR-480227
2"
CLD
011
200305
101CH2S
SA-JER-DS011-TRJR-480275
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
SA-JER-DS011-TRJR-480227
4"
CLD
011
200305
101CH2S
Insul Brk
6"-CLD-011078321-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
SA-JER-DS011-TRJR-480274
2"
CLD
011
200306
101CH2S
2"-JET-011200001-103CS1P-N
SA-JER-DS011-TRJR-480228
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
SA-JER-DS011-TRJR-480228
2"
CLD
011
200306
101CH2S
SA-JER-DS011-TRJR-480274
2"-CLD-011025301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
SA-JER-DS011-TRJR-480274
2"
CLD
011
200307
101CH2S
2"-HFO-011200003-103CS1P-N
SA-JER-DS011-TRJR-480229
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
M
Y
N
N
SA-JER-DS011-TRJR-480229
2"
CLD
011
200307
101CH2S
SA-JER-DS011-TRJR-480274
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
M
Y
N
N
SA-JER-DS011-TRJR-480229
4"
CLD
011
200307
101CH2S
Insul Brk
4"-CLD-011025304-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
SA-JER-DS011-TRJR-480275
2"
CLD
011
200308
101CH2S
2"-CWS-011033018-106CH2S-N
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
SA-JER-DS011-TRJR-380001
BENCENE
Q
Y
N
N
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
-
N
N
-
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
-
N
N
-
N
N
-
N
N
-
N
N
N
-
N
N
N
-
N
N
N
N
-
N
N
N
N
-
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
Page 40 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
2"-CLD-011033312-101CH2S-N
-
-
N
-
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
(NOTE 7)
SA-JER-DS011-TRJR-480226
2"
CLD
011
200308
101CH2S
SA-JER-DS011-TRJR-480275
SA-JER-DS011-TRJR-480275
2"
CLD
011
200309
101CH2S
2"-PRO-011033021-103CH2S-N
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
200309
101CH2S
SA-JER-DS011-TRJR-480275
4"-CLD-011200309-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
4"
CLD
011
200309
101CH2S
2"-CLD-011200309-101CH2S-N
6"-CLD-011078302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480275
2"
CLD
011
200310
101CH2S
2"-CWS-011021003-101CH2S-N
SA-JER-DS011-TRJR-480227
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
200310
101CH2S
SA-JER-DS011-TRJR-480275
4"-CLD-011200310-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
43.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
200310
101CH2S
2"-CLD-011200310-101CH2S-N
4"-CLD-011200303-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480275
2"
CLD
011
200312
101CH2S
2"-CWS-011036004-101CH2S-N
SA-JER-DS011-TRJR-480226
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
41.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480226
2"
CLD
011
200312
101CH2S
SA-JER-DS011-TRJR-480275
2"-CLD-011200308-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
41.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480274
3/4"
CLD
011
200313
103CS1P
SAMPLE COOLER
Reducer
-
-
N
-
HC CLOSED DRAIN
Liquid
983
13.50
60.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
A or Q
Y
N
N
N
N
N
-
NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR. NOTE 6. FOR THE UNDERGROUND PORTION OF THE CLOSE DRAIN LINES, THE PAINT SYSTEM TO BE USED IS INTERTHERM 228 or SIMILAR.
SA-JER-DS011-TRJR-480274
4"
CLD
011
200313
103CS1P
Reducer
Reducer
-
-
N
-
HC CLOSED DRAIN
Liquid
983
13.50
60.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480274
1/2"
CLD
011
200313
103CS1P
Reducer
SO
-
-
N
-
HC CLOSED DRAIN
Liquid
983
13.50
60.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480274
3/4"
CLD
011
200314
103CS1P
SAMPLE COOLER
Reducer
-
-
N
-
HC CLOSED DRAIN
Liquid
922
12.00
60.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480274
4"
CLD
011
200314
103CS1P
Reducer
Reducer
-
-
N
-
HC CLOSED DRAIN
Liquid
922
12.00
60.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480274
1/2"
CLD
011
200314
103CS1P
Reducer
SO
-
-
N
-
HC CLOSED DRAIN
Liquid
922
12.00
60.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480274
2"
CLD
011
200315
101CH2S
2"-BRN-011200003-103CS4P-N
SA-JER-DS011-TRJR-480228
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
60.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
2"
CLD
011
200315
101CH2S
SA-JER-DS011-TRJR-480274
4"-CLD-011200315-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
60.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
4"
CLD
011
200315
101CH2S
2"-CLD-011200315-101CH2S-N
6"-CLD-011078316-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480274
2"
CLD
011
200316
101CH2S
2"-BRN-011200004-106CS2P-N
SA-JER-DS011-TRJR-480231
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
60.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
200316
101CH2S
SA-JER-DS011-TRJR-480274
4"-CLD-011200316-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
60.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
200316
101CH2S
2"-CLD-011200316-101CH2S-N
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480274
2"
CLD
011
200317
101CH2S
2"-BDH-011200002-101CS1P-N
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
200317
101CH2S
SA-JER-DS011-TRJR-480274
2"-CLD-011200318-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480274
2"
CLD
011
200318
101CH2S
2"-LPS-011200002-101CS1P-N
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
200318
101CH2S
SA-JER-DS011-TRJR-480274
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
200318
101CH2S
Insul Brk
4"-CLD-011040310-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480274
2"
CLD
011
200321
101CH2S
2"-BFW-011200302-101CS1P-N
SA-JER-DS011-TRJR-480228
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480228
2"
CLD
011
200321
101CH2S
SA-JER-DS011-TRJR-480274
2"-CLD-011037308-101CH2S-P
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
-0.50
200.00
-
H
5.25
NFS
YES
Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480273
2"
CLD
011
200325
101CH2S
2"-HFO-011200101-103CS1P-N
SA-JER-DS011-TRJR-480231
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
60.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
2"
CLD
011
200325
101CH2S
SA-JER-DS011-TRJR-480273
4"-CLD-011200325-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
60.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480231
4"
CLD
011
200325
101CH2S
2"-CLD-011200325-101CH2S-N
4"-CLD-011040302-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480273
2"
CLD
011
200326
101CH2S
2"-HFO-011200102-103CL4P-N
SA-JER-DS011-TRJR-480227
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
60.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
2"
CLD
011
200326
101CH2S
SA-JER-DS011-TRJR-480273
4"-CLD-011200326-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
60.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480227
4"
CLD
011
200326
101CH2S
2"-CLD-011200326-101CH2S-N
6"-CLD-011078321-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
60.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480275
2"
CLD
011
200329
101CH2S
2"-SLP-011001004-103CS1P-N
SA-JER-DS011-TRJR-480229
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
40.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
200329
101CH2S
SA-JER-DS011-TRJR-480275
4"-CLD-011200329-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
40.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
4"
CLD
011
200329
101CH2S
2"-CLD-011200329-101CH2S-N
4"-CLD-011001307-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480289
2"
CLD
011
230301
101CH2S
2"-DIE-011230001-101CS1P-N
SA-JER-DS011-TRJR-480229
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
2"
CLD
011
230301
101CH2S
SA-JER-DS011-TRJR-480289
4"-CLD-011230301-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
50.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480229
4"
CLD
011
230301
101CH2S
2"-CLD-011230301-101CH2S-N
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480290
2"
CLD
011
230302
101CH2S
2"-HFO-011230101-101CS1P-P
SA-JER-DS011-TRJR-480216
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
2"
CLD
011
230302
101CH2S
SA-JER-DS011-TRJR-480290
Insul Brk
-
-
P
25
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480216
4"
CLD
011
230302
101CH2S
Insul Brk
6"-CLD-011078317-101CH2S-N
-
-
N
-
HC CLOSED DRAIN
Liquid
1000
0.50
25.00
-
170.00
3.50
200.00
-
H
5.25
NFS
YES
B or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480201
1"
CND
011
071302
103CS1P
011-G-0028-A
Reducer
-
-
H
25
Liquid
932
15.10
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
3"
CND
011
071302
103CS1P
Reducer
Reducer
-
-
H
40
Liquid
932
15.10
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
1/2"
CND
011
071302
103CS1P
011-FT-0195
011-FE-0195
-
-
H
25
Liquid
932
15.10
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
3/4"
CND
011
071302
103CS1P
3"-CND-011071302-103CS1P-H
Plug
-
-
H
25
Liquid
932
15.10
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
3/4"
CND
011
071302
103CS1P
3"-CND-011071302-103CS1P-H
Plug
-
-
H
25
Liquid
932
15.10
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
1/2"
CND
011
071302
103CS1P
011-FT-0195
011-FE-0195
-
-
H
25
Liquid
932
15.10
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
3/4"
CND
011
071302
103CS1P
011-PI-0421
3"-CND-011071302-103CS1P-H
-
-
H
25
Liquid
932
15.10
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
3"
CND
011
071302
103CS1P
3"-CND-011071302-103CS1P-H
Reducer
-
-
H
40
Liquid
932
15.10
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE
Page 41 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
INSULATION (NOTE 2)
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
SA-JER-DS011-TRJR-480201
1-1/2"
CND
011
071302
103CS1P
Reducer
1-1/2"-CND-011071302-103CS1PH
-
-
H
40
SA-JER-DS011-TRJR-480250
1/2"
CND
011
071302
103CS1P
SA-JER-DS011-TRJR-480201
2"-OLW-011171332-101CS1P-N
-
-
P
25
SA-JER-DS011-TRJR-480201
1-1/2"
CND
011
071302
103CS1P
Reducer
Reducer
-
-
H
40
SA-JER-DS011-TRJR-480202
3"
CND
011
071302
103CS1P
SA-JER-DS011-TRJR-480201
Reducer
-
-
H
40
SA-JER-DS011-TRJR-480202
3"
CND
011
071302
103CS1P
HEADER
3"-CND-011071302-103CS1P-H
-
-
H
40
SA-JER-DS011-TRJR-480202
4"
CND
011
071302
103CS1P
Reducer
Reducer
-
-
H
50
SA-JER-DS011-TRJR-480202
3"
CND
011
071302
103CS1P
Reducer
IP-1330 L
-
-
H
40
SA-JER-DS011-TRJR-480202
2"
CND
011
071302
103CS1P
011-TT-0251
4"-CND-011071302-103CS1P-H
-
-
H
40
SA-JER-DS011-TRJR-480202
3/4"
CND
011
071302
103CS1P
3"-CND-011071302-103CS1P-H
Plug
-
-
H
25
SA-JER-DS011-TRJR-480202
3/4"
CND
011
071302
103CS1P
011-PI-0269
3"-CND-011071302-103CS1P-H
-
-
H
25
SA-JER-DS011-TRJR-480201
3"
CND
011
071302
103CS1P
Reducer
3"-CND-011071302-103CS1P-H
-
-
H
40
SA-JER-DS011-TRJR-480201
3/4"
CND
011
071302
103CS1P
3"-CND-011071302-103CS1P-H
Plug
-
-
H
25
SA-JER-DS011-TRJR-480201
3"
CND
011
071302
103CS1P
3"-CND-011071302-103CS1P-H
SA-JER-DS011-TRJR-480202
-
-
H
40
SA-JER-DS011-TRJR-480201
1/2"
CND
011
071302
103CS1P
011-FT-0176
011-FE-0176
-
-
H
25
SA-JER-DS011-TRJR-480201
3"
CND
011
071302
103CS1P
Reducer
3"-CND-011071302-103CS1P-H
-
-
H
40
SA-JER-DS011-TRJR-480201
1/2"
CND
011
071302
103CS1P
011-FT-0176
011-FE-0176
-
-
H
25
SA-JER-DS011-TRJR-480201
1-1/2"
CND
011
071302
103CS1P
1-1/2"-CND-011071302-103CS1PH
Reducer
-
-
H
40
SA-JER-DS011-TRJR-480201
1/2"
CND
011
071302
103CS1P
Gate valve
1/2"-CND-011071302-103CS1P-P
-
-
P
25
SA-JER-DS011-TRJR-480201
1/2"
CND
011
071302
103CS1P 1/2"-CND-011071302-103CS1P-P
SA-JER-DS011-TRJR-480250
-
-
P
25
SA-JER-DS011-TRJR-480201
4"
CND
011
071303
103CS1P
4"-LPC-011071002-101CS1P-H
Reducer
-
-
H
50
SA-JER-DS011-TRJR-480201
3/4"
CND
011
071303
103CS1P
4"-CND-011071303-103CS1P-H
UC
-
-
H
25
SA-JER-DS011-TRJR-480201
3/4"
CND
011
071303
103CS1P
4"-CND-011071303-103CS1P-H
Gate valve
-
-
H
25
SA-JER-DS011-TRJR-480201
3/4"
CND
011
071303
103CS1P
4"-CND-011071303-103CS1P-H
Plug
-
-
H
25
SA-JER-DS011-TRJR-480201
3"
CND
011
071303
103CS1P
Reducer
011-G-0028-A
-
-
H
40
SA-JER-DS011-TRJR-480201
4"
CND
011
071304
103CS1P
4"-LPC-011071002-101CS1P-H
Reducer
-
-
H
50
SA-JER-DS011-TRJR-480201
3/4"
CND
011
071304
103CS1P
4"-CND-011071304-103CS1P-H
Plug
-
-
H
25
SA-JER-DS011-TRJR-480201
3/4"
CND
011
071304
103CS1P
4"-CND-011071304-103CS1P-H
UC
-
-
H
25
SA-JER-DS011-TRJR-480201
3/4"
CND
011
071304
103CS1P
4"-CND-011071304-103CS1P-H
011-PI-0324
-
-
H
25
SA-JER-DS011-TRJR-480201
3"
CND
011
071304
103CS1P
Reducer
011-G-0028-B
-
-
H
40
SA-JER-DS011-TRJR-480201
1"
CND
011
071306
103CS1P
011-G-0028-B
Reducer
-
-
H
25
SA-JER-DS011-TRJR-480201
3"
CND
011
071306
103CS1P
Reducer
3"-CND-011071302-103CS1P-H
-
-
H
40
SA-JER-DS011-TRJR-480201
3/4"
CND
011
071306
103CS1P
3"-CND-011071306-103CS1P-H
Plug
-
-
H
25
SA-JER-DS011-TRJR-480201
3/4"
CND
011
071306
103CS1P
011-PI-0422
3"-CND-011071306-103CS1P-H
-
-
H
25
SA-JER-DS011-TRJR-480250
1/2"
CND
011
071306
103CS1P
SA-JER-DS011-TRJR-480201
2"-OLW-011171333-101CS1P-N
-
-
P
25
SA-JER-DS011-TRJR-480201
1/2"
CND
011
071306
103CS1P
Gate valve
1/2"-CND-011071306-103CS1P-P
-
-
P
25
SA-JER-DS011-TRJR-480201
1/2"
CND
011
071306
103CS1P 1/2"-CND-011071306-103CS1P-P
SA-JER-DS011-TRJR-480250
-
-
P
25
SA-JER-DS011-TRJR-480201
3/4"
CND
011
071307
103CS1P
011-SC-0050
-
-
H
25
SA-JER-DS011-TRJR-480274
3/4"
CND
011
071307
103CS1P 3/4"-CND-011071302-103CS1P-H
SAMPLE COOLER
-
-
H
25
3"-CND-011071302-103CS1P-H
FLUID
PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE PUMPED HOT CONDENSATE
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
Liquid
932
15.10
134.00
-
-
29.00
Liquid
932
0.00
27.00
-
-
0.00
Liquid
932
15.10
134.00
-
-
Liquid
932
11.50
134.00
-
Liquid
932
11.50
134.00
-
Liquid
932
11.50
134.00
Liquid
932
11.50
Liquid
932
Liquid
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
60.00
-
H
0.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
11.50
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
932
11.50
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
11.50
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
15.10
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
15.10
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
11.50
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
11.50
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
11.50
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
11.50
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
11.50
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
15.10
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
0.00
27.00
-
-
0.00
60.00
-
H
0.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
2.00
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
2.00
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
2.00
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
2.00
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
2.00
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
2.00
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
2.00
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
2.00
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
2.00
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
2.00
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
15.10
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
15.10
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
15.10
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
15.10
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
0.00
27.00
-
-
0.00
60.00
-
H
0.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
15.10
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
0.00
27.00
-
-
0.00
60.00
-
H
0.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
11.50
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
11.50
134.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE.
Liquid
932
2.00
134.00
-
-
3.50
150.00
-
H
5.25
ASME N/A
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
2.00
134.00
-
-
3.50
150.00
-
H
5.25
ASME N/A
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
2.00
134.00
-
-
3.50
150.00
-
H
5.25
ASME N/A
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
2.00
134.00
-
-
3.50
150.00
-
H
5.25
ASME N/A
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
2.00
134.00
-
-
3.50
150.00
-
H
5.25
ASME N/A
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
2.00
134.00
-
-
3.50
150.00
-
H
5.25
ASME N/A
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
2.00
134.00
-
-
3.50
150.00
-
H
5.25
ASME N/A
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
2.00
134.00
-
-
3.50
150.00
-
H
5.25
ASME N/A
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
2.00
134.00
-
-
3.50
150.00
-
H
5.25
ASME N/A
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
2.00
134.00
-
-
3.50
150.00
-
H
5.25
ASME N/A
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
2.00
134.00
-
-
3.50
150.00
-
H
5.25
ASME N/A
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
932
11.50
60.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
Liquid
932
11.50
60.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
Liquid
932
11.50
60.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
Liquid
932
11.50
60.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
Liquid
932
11.50
60.00
-
-
29.00
150.00
-
H
43.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
(NOTE 7)
-
SA-JER-DS011-TRJR-480201
1-1/2"
CND
011
071308
103CS1P
3"-CND-011071302-103CS1P-H
Reducer
-
-
H
40
SA-JER-DS011-TRJR-480201
1-1/2"
CND
011
071308
103CS1P
1-1/2"-CND-011071308-103CS1PH
Reducer
-
-
H
40
SA-JER-DS011-TRJR-480201
1/2"
CND
011
071308
103CS1P
Reducer
1/2"-CND-011071309-101CS1P-H
-
-
H
25
SA-JER-DS011-TRJR-480201
3/4"
CND
011
071308
103CS1P
Plug
-
-
H
25
SA-JER-DS011-TRJR-480201
3/4"
CND
011
071308
103CS1P
Plug
-
-
H
25
SA-JER-DS011-TRJR-480201
1"
CND
011
071308
103CS1P
Reducer
Reducer
-
-
H
25
SA-JER-DS011-TRJR-480201
1-1/2"
CND
011
071308
103CS1P
Reducer
1-1/2"-CND-011071309-101CS1PH
-
-
H
40
SA-JER-DS011-TRJR-480201
1-1/2"
CND
011
071309
101CS1P
1-1/2"-CND-011071308-103CS1PH
Reducer
-
-
H
40
SA-JER-DS011-TRJR-480201
1/2"
CND
011
071309
101CS1P 1/2"-CND-011071308-103CS1P-H
Reducer
-
-
H
25
SA-JER-DS011-TRJR-480201
1-1/2"
CND
011
071309
101CS1P
Reducer
1-1/2"-CND-011071309-101CS1PH
-
-
H
40
SA-JER-DS011-TRJR-480201
2"
CND
011
071309
101CS1P
Reducer
011-D-0026
-
-
H
40
SA-JER-DS011-TRJR-480274
3/4"
CND
011
200301
103CS1P
SAMPLE COOLER
Reducer
-
-
N
-
SA-JER-DS011-TRJR-480274
4"
CND
011
200301
103CS1P
Reducer
Reducer
-
-
N
-
SA-JER-DS011-TRJR-480274
3/4"
CND
011
200301
103CS1P
Reducer
SO
-
-
N
-
SA-JER-DS011-TRJR-480274
3/4"
CND
011
200302
103CS1P 3/4"-CND-011200301-103CS1P-N
Reducer
-
-
N
-
SA-JER-DS011-TRJR-480274
2"
CND
011
200302
103CS1P
Reducer
1"-OLW-011200326-101CS1P-N
-
-
N
-
SA-JER-DS011-TRJR-480002
10"
CRU
011
001002
103CS1P
10"-CRU-011001017-106CS1P-N
SA-JER-DS011-TRJR-480001
-
-
N
-
FRESH CRUDE
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480001
10"
CRU
011
001002
103CS1P
SA-JER-DS011-TRJR-480002
18"-CRU-011098001-103CS1P-N
-
-
N
-
FRESH CRUDE
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
18"
CRU
011
001003
106CS1P
18"-CRU-011098001-103CS1P-N
011-G-0001-A
-
-
N
-
FRESH CRUDE
Liquid
874
2.00
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
18"
CRU
011
001004
106CS1P
18"-CRU-011098001-103CS1P-N
011-G-0001-B
-
-
N
-
FRESH CRUDE
Liquid
874
2.00
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
12"
CRU
011
001005
106CS1P
011-G-0001-A
Reducer
-
-
N
-
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
16"
CRU
011
001005
106CS1P
Reducer
Insul Brk
-
-
N
-
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
16"
CRU
011
001005
106CS1P
SA-JER-DS011-TRJR-480002
011-E-0001
-
-
H
40
FRESH CRUDE
Liquid
874
27.00
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
16"
CRU
011
001005
106CS1P
16"-CRU-011001005-106CS1P-H
011-E-0001
-
-
H
40
FRESH CRUDE
Liquid
874
27.00
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
2"
CRU
011
001005
106CS1P
16"-CRU-011001005-106CS1P-H
011-TT-0002
-
-
H
25
FRESH CRUDE
Liquid
874
27.00
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
16"
CRU
011
001005
106CS1P
Insul Brk
Reducer
-
-
H
40
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
16"
CRU
011
001005
106CS1P
16"-CRU-011001005-106CS1P-H
Reducer
-
-
H
40
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
3/4"
CRU
011
001005
106CS1P
16"-CRU-011001005-106CS1P-H
011-PT-0002
-
-
H
25
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
1/2"
CRU
011
001005
106CS1P
011-FE-0001
011-FT-0001
-
-
H
25
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
1/2"
CRU
011
001005
106CS1P
011-FE-0001
011-FT-0001
-
-
H
25
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
8"
CRU
011
001005
106CS1P
Reducer
8"-CRU-011001005-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
12"
CRU
011
001005
106CS1P
Reducer
Reducer
-
-
H
40
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
16"
CRU
011
001005
106CS1P
Reducer
16"-CRU-011001005-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
16"
CRU
011
001005
106CS1P
16"-CRU-011001005-106CS1P-H
SA-JER-DS011-TRJR-480003
-
-
H
40
FRESH CRUDE
Liquid
874
27.00
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
8"-CRU-011001005-106CS1P-H
Reducer
-
-
H
40
FRESH CRUDE
Liquid
874
27.00
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
40
874
27.00
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
1-1/2"-CND-011071308-103CS1PH 1-1/2"-CND-011071308-103CS1PH
SA-JER-DS011-TRJR-480002
8"
CRU
011
001005
106CS1P
SA-JER-DS011-TRJR-480002
16"
CRU
011
001005
106CS1P
Reducer
16"-CRU-011001005-106CS1P-H
-
FRESH CRUDE
Liquid
SA-JER-DS011-TRJR-480002
16"
CRU
011
001005
106CS1P
12"-SLP-011098019-103CS1P-H
16"-CRU-011001005-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
20"
CRU
011
001006
106CS1P
011-E-0001
Reducer
-
-
H
40
FRESH CRUDE
Liquid
867
26.30
50.40
-
-
50.00
95.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
16"
CRU
011
001006
106CS1P
Reducer
011-E-0002
-
-
H
40
FRESH CRUDE
Liquid
867
26.30
50.40
-
-
50.00
95.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 42 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
TO
TYPE
INSULATION (NOTE 2)
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480003
2"
CRU
011
001006
106CS1P
16"-CRU-011001006-106CS1P-H
011-TT-0004
-
-
H
25
FRESH CRUDE
Liquid
867
26.30
50.40
-
-
50.00
95.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
16"
CRU
011
001006
106CS1P
16"-CRU-011001006-106CS1P-H
011-E-0002
-
-
H
40
FRESH CRUDE
Liquid
867
26.30
50.40
-
-
50.00
95.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
20"
CRU
011
001007
106CS1P
011-E-0002
Reducer
-
-
H
40
FRESH CRUDE
Liquid
862
25.70
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
16"
CRU
011
001007
106CS1P
Reducer
SA-JER-DS011-TRJR-480004
-
-
H
40
FRESH CRUDE
Liquid
862
25.70
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
2"
CRU
011
001007
106CS1P
16"-CRU-011001007-106CS1P-H
011-TT-0005
-
-
H
25
FRESH CRUDE
Liquid
862
25.70
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
16"
CRU
011
001007
106CS1P
SA-JER-DS011-TRJR-480003
Reducer
-
-
H
40
FRESH CRUDE
Liquid
862
25.70
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
16"
CRU
011
001007
106CS1P
16"-CRU-011001007-106CS1P-H
Reducer
-
-
H
40
FRESH CRUDE
Liquid
862
25.70
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
12"
CRU
011
001007
106CS1P
Reducer
12"-CRU-011001007-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
862
25.70
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
14"
CRU
011
001007
106CS1P
Reducer
Reducer
-
-
H
40
FRESH CRUDE
Liquid
862
25.70
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480004
16"
CRU
011
001007
106CS1P
Reducer
16"-CRU-011001007-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
862
25.70
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
16"
CRU
011
001007
106CS1P
16"-CRU-011001007-106CS1P-H
Reducer
-
-
H
40
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
16"
CRU
011
001007
106CS1P
16"-CRU-011001007-106CS1P-H
Reducer
-
-
H
40
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
16"
CRU
011
001007
106CS1P
Reducer
16"-CRU-011001007-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
12"
CRU
011
001007
106CS1P
12"-CRU-011001007-106CS1P-H
Reducer
-
-
H
40
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
12"
CRU
011
001007
106CS1P
Reducer
Reducer
-
-
H
40
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
001007
106CS1P
12"-CRU-011001007-106CS1P-H
011-TT-0066
-
-
H
25
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
001007
106CS1P
12"-CRU-011001007-106CS1P-H
Blind flange
-
-
H
25
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
001007
106CS1P
12"-CRU-011001007-106CS1P-H
Blind flange
-
-
H
25
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
12"
CRU
011
001007
106CS1P
12"-CRU-011001007-106CS1P-H
Reducer
-
-
H
40
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
001007
106CS1P
12"-CRU-011001007-106CS1P-H
011-TT-0078
-
-
H
25
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
001007
106CS1P
Insul Brk
12"-CRU-011001007-106CS1P-H
-
-
H
25
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
12"
CRU
011
001007
106CS1P
12"-CRU-011001007-106CS1P-H
Reducer
-
-
H
40
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
12"
CRU
011
001007
106CS1P
Reducer
Reducer
-
-
H
40
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
001007
106CS1P
Insul Brk
12"-CRU-011001007-106CS1P-H
-
-
H
25
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
10"
CRU
011
001007
106CS1P
Reducer
011-E-0003-A/B/C/D
-
-
H
40
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
10"
CRU
011
001007
106CS1P
Reducer
011-E-0003-D
-
-
H
40
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
10"
CRU
011
001007
106CS1P
Reducer
011-E-0003-C
-
-
H
40
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
10"
CRU
011
001007
106CS1P
Reducer
011-E-0003-B
-
-
H
40
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
3/4"
CRU
011
001010
106CS1P
10"-CRU-011001017-106CS1P-N
Reducer
-
-
N
-
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
2"
CRU
011
001010
106CS1P
Reducer
2"-CLD-011001303-101CH2S-P
-
-
N
-
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
3/4"
CRU
011
001011
106CS1P
16"-CRU-011001005-106CS1P-H
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
3/4"
CRU
011
001011
106CS1P
Insul Brk
Reducer
-
-
N
-
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
2"
CRU
011
001011
106CS1P
Reducer
2"-CLD-011001304-101CH2S-N
-
-
N
-
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
2"
CRU
011
001012
106CS1P
16"-CRU-011001005-106CS1P-N
2"-CLD-011001309-101CH2S-N
-
-
N
-
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
3/4"
CRU
011
001012
106CS1P
011-G-0001-A
Reducer
-
-
N
-
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
2"
CRU
011
001012
106CS1P
Reducer
2"-CRU-011001012-106CS1P-N
-
-
N
-
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
2"
CRU
011
001012
106CS1P
18"-CRU-011001003-106CS1P-N
2"-CRU-011001012-106CS1P-N
-
-
N
-
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
3/4"
CRU
011
001012
106CS1P
011-G-0001-A
2"-CRU-011001012-106CS1P-N
-
-
N
-
NAPHTHA
Gas
-
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
2"
CRU
011
001013
106CS1P
16"-CRU-011001016-106CS1P-N
2"-CLD-011001308-101CH2S-N
-
-
N
-
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
3/4"
CRU
011
001013
106CS1P
011-G-0001-B
Reducer
-
-
N
-
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
2"
CRU
011
001013
106CS1P
Reducer
2"-CRU-011001013-106CS1P-N
-
-
N
-
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
2"
CRU
011
001013
106CS1P
18"-CRU-011001004-106CS1P-N
2"-CRU-011001013-106CS1P-N
-
-
N
-
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
3/4"
CRU
011
001013
106CS1P
011-G-0001-B
2"-CRU-011001013-106CS1P-N
-
-
N
-
NAPHTHA
Gas
-
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
12"
CRU
011
001016
106CS1P
011-G-0001-B
Reducer
-
-
N
-
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
16"
CRU
011
001016
106CS1P
Reducer
16"-CRU-011001005-106CS1P-N
-
-
N
-
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
10"
CRU
011
001017
106CS1P
16"-CRU-011001005-106CS1P-N
Reducer
-
-
N
-
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
8"
CRU
011
001017
106CS1P
Reducer
Reducer
-
-
N
-
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
10"
CRU
011
001017
106CS1P
Reducer
10"-CRU-011001002-103CS1P-N
-
-
N
-
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
3/4"
CRU
011
001020
106CS1P
16"-CRU-011001005-106CS1P-H
011-SC-0001
-
-
H
25
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
1/2"
CRU
011
001020
106CS1P
Reducer
SO
-
-
N
-
FRESH CRUDE
Liquid
874
33.80
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
2"
CRU
011
001022
106CS1P
16"-CRU-011001005-106CS1P-H
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid
874
27.00
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
2"
CRU
011
001022
106CS1P
Insul Brk
2"-CLD-011001301-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
874
27.00
40.00
-
-
50.00
80.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
2"
CRU
011
001023
106CS1P
16"-CRU-011001006-106CS1P-H
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid
867
26.30
50.40
-
-
50.00
95.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
2"
CRU
011
001023
106CS1P
Insul Brk
2"-CLD-011001313-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
867
26.30
50.40
-
-
50.00
95.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
10"
CRU
011
002001
106CS1P
16"-CRU-011001007-106CS1P-H
Reducer
-
-
H
40
FRESH CRUDE
Liquid
862
25.70
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
8"
CRU
011
002001
106CS1P
Reducer
Reducer
-
-
H
40
FRESH CRUDE
Liquid
862
25.70
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 8
SA-JER-DS011-TRJR-480004
10"
CRU
011
002001
106CS1P
Reducer
10"-CRU-011002001-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
862
25.70
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
10"
CRU
011
002001
106CS1P
10"-CRU-011002001-106CS1P-H 16"-CRU-011002002-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
862
22.00
56.80
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
10"
CRU
011
002002
106CS1P
011-E-0003-A/B/C/D
Reducer
-
-
H
40
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
002002
106CS1P
10"-CRU-011002002-106CS1P-H
011-TT-0008
-
-
H
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
002002
106CS1P
10"-CRU-011002002-106CS1P-H
011-TT-0007
-
-
H
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
10"
CRU
011
002002
106CS1P
011-E-0003-B
Reducer
-
-
H
40
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
10"
CRU
011
002002
106CS1P
011-E-0003-C
Reducer
-
-
H
40
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
10"
CRU
011
002002
106CS1P
011-E-0003-D
Reducer
-
-
H
40
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
002002
106CS1P
10"-CRU-011002002-106CS1P-H
011-TT-0010
-
-
H
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
002002
106CS1P
10"-CRU-011002002-106CS1P-H
011-TT-0009
-
-
H
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
12"
CRU
011
002002
106CS1P
Reducer
Reducer
-
-
H
40
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
12"
CRU
011
002002
106CS1P
Reducer
Reducer
-
-
H
40
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
12"
CRU
011
002002
106CS1P
Reducer
12"-CRU-011002002-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
12"
CRU
011
002002
106CS1P
Reducer
12"-CRU-011002002-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
16"
CRU
011
002002
106CS1P
SA-JER-DS011-TRJR-480004
Reducer
-
-
H
40
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
16"
CRU
011
002002
106CS1P
16"-CRU-011002002-106CS1P-H
Reducer
-
-
H
40
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
12"
CRU
011
002002
106CS1P
Reducer
Reducer
-
-
H
40
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
12"
CRU
011
002002
106CS1P
Reducer
Reducer
-
-
H
40
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
16"
CRU
011
002002
106CS1P
Reducer
011-E-0004-A/B
-
-
H
40
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
16"
CRU
011
002002
106CS1P
Reducer
011-E-0004-B
-
-
H
40
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
16"
CRU
011
002002
106CS1P
Reducer
SA-JER-DS011-TRJR-480005
-
-
H
40
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
002002
106CS1P
16"-CRU-011002002-106CS1P-H
011-TT-0011
-
-
H
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
16"
CRU
011
002002
106CS1P
Reducer
16"-CRU-011002002-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
002003
106CS1P
12"-CRU-011002002-106CS1P-H
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
002003
106CS1P
Insul Brk
2"-CLD-011002301-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
002003
106CS1P
2"-CRU-011002003-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
002004
106CS1P
12"-CRU-011002002-106CS1P-H
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
002004
106CS1P
Insul Brk
2"-CLD-011002303-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
002004
106CS1P
2"-CRU-011002004-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
3/4"
CRU
011
002005
106CS1P
10"-CRU-011002001-106CS1P-H
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid
862
25.70
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
3/4"
CRU
011
002005
106CS1P
Insul Brk
Reducer
-
-
N
-
FRESH CRUDE
Liquid
862
25.70
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
002005
106CS1P
Reducer
2"-CLD-011002305-101CH2S-N
-
-
N
-
FRESH CRUDE
Liquid
862
25.70
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
3/4"
CRU
011
002005
106CS1P
10"-CRU-011002001-106CS1P-H
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid
862
25.70
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
3/4"
CRU
011
002005
106CS1P
Insul Brk
3/4"-CRU-011002005-106CS1P-N
-
-
N
-
FRESH CRUDE
Liquid
862
25.70
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
3/4"
CRU
011
002008
106CS1P
16"-CRU-011001007-106CS1P-H
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid
862
25.70
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 43 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
-
FLUID
THICKNESS (mm)
(NOTE 3)
(NOTE 4) 862
OPERATING CONDITIONS PRESS. (BARG) 25.70
TEMP. (ºC) 56.80
DESIGN CONDITIONS
ALTERNATE CONDITIONS PRESS. (BARG) -
TEMP. (ºC) -
PRESS. (BARG) 50.00
TEMP. (ºC) 100.00
STRESS TEMP
(ºC) -
TEST CONDITIONS
MEDIUM (NOTE 5) H
PRESS. (BARG) 75.00
FLUID CATEGORY (ASME B.31.3)
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6) NFS
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
3/4"
CRU
011
002008
106CS1P
Insul Brk
Reducer
-
N
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480004
2"
CRU
011
002008
106CS1P
Reducer
2"-CLD-011002306-101CH2S-N
-
-
N
-
FRESH CRUDE
Liquid
862
25.70
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
002009
106CS1P
UC
Insul Brk
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC.
SA-JER-DS011-TRJR-480004
3/4"
CRU
011
002009
106CS1P
2"-CRU-011002009-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC.
SA-JER-DS011-TRJR-480004
2"
CRU
011
002009
106CS1P
Insul Brk
12"-CRU-011002002-106CS1P-H
-
-
H
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC.
SA-JER-DS011-TRJR-480004
2"
CRU
011
002010
106CS1P
UC
Insul Brk
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC.
SA-JER-DS011-TRJR-480004
3/4"
CRU
011
002010
106CS1P
2"-CRU-011002010-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC.
SA-JER-DS011-TRJR-480004
2"
CRU
011
002010
106CS1P
Insul Brk
12"-CRU-011002002-106CS1P-H
-
-
H
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC.
SA-JER-DS011-TRJR-480004
2"
CRU
011
002011
106CS1P
12"-CRU-011001007-106CS1P-H
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
002011
106CS1P
Insul Brk
2"-CLD-011002307-101CH2S-N
-
-
P
25
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
002011
106CS1P
2"-CRU-011002011-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
002012
106CS1P
12"-CRU-011001007-106CS1P-H
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
002012
106CS1P
Insul Brk
2"-CLD-011002308-101CH2S-N
-
-
P
25
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
CRU
011
002012
106CS1P
2"-CRU-011002012-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
862
22.02
56.80
-
-
50.00
100.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
10"
CRU
011
003001
106CS1P
16"-CRU-011002002-106CS1P-H 10"-CRU-011003001-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
10"
CRU
011
003001
106CS1P
10"-CRU-011003001-106CS1P-H 10"-CRU-011003001-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
10"
CRU
011
003001
106CS1P
10"-CRU-011003001-106CS1P-H
011-TV-0016
-
-
H
40
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
10"
CRU
011
003001
106CS1P
011-TV-0016
10"-CRU-011003001-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
839
22.00
80.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
10"
CRU
011
003001
106CS1P
10"-CRU-011003001-106CS1P-H 16"-CRU-011003002-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
847
21.30
92.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
10"
CRU
011
003001
106CS1P
10"-CRU-011003001-106CS1P-H 10"-CRU-011003001-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
847
21.30
92.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
16"
CRU
011
003002
106CS1P
011-E-0004-A/B
Reducer
-
-
H
40
FRESH CRUDE
Liquid
839
21.30
92.00
-
170.00
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
16"
CRU
011
003002
106CS1P
011-E-0004-B
Reducer
-
-
H
40
FRESH CRUDE
Liquid
839
21.30
92.00
-
170.00
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
12"
CRU
011
003002
106CS1P
Reducer
Reducer
-
-
H
40
FRESH CRUDE
Liquid
839
21.30
92.00
-
170.00
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003002
106CS1P
12"-CRU-011003002-106CS1P-H
011-TT-0013
-
-
H
25
FRESH CRUDE
Liquid
839
21.30
92.00
-
170.00
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003002
106CS1P
2"-FLO-011003302-101CS1P-N
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid
839
21.30
92.00
-
170.00
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003002
106CS1P
12"-CRU-011003002-106CS1P-H
011-TT-0012
-
-
H
25
FRESH CRUDE
Liquid
839
21.30
92.00
-
170.00
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003002
106CS1P
Insul Brk
12"-CRU-011003002-106CS1P-H
-
-
H
25
FRESH CRUDE
Liquid
839
21.30
92.00
-
170.00
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
3/4"
CRU
011
003002
106CS1P
2"-CRU-011003002-106CS1P-P
Blind flange
-
-
H
25
FRESH CRUDE
Liquid
839
21.30
92.00
-
170.00
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
3/4"
CRU
011
003002
106CS1P
2"-CRU-011003002-106CS1P-P
Blind flange
-
-
H
25
FRESH CRUDE
Liquid
839
21.30
92.00
-
170.00
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
12"
CRU
011
003002
106CS1P
Reducer
Reducer
-
-
H
40
FRESH CRUDE
Liquid
839
21.30
92.00
-
170.00
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003002
106CS1P
2"-CRU-011003002-106CS1P-H
Blind flange
-
-
H
25
FRESH CRUDE
Liquid
839
21.30
92.00
-
170.00
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003002
106CS1P
Insul Brk
12"-CRU-011003002-106CS1P-H
-
-
H
25
FRESH CRUDE
Liquid
839
21.30
92.00
-
170.00
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003002
106CS1P
2"-FLO-011003301-101CS1P-N
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid
839
21.30
92.00
-
170.00
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003002
106CS1P
2"-CRU-011003002-106CS1P-H
Blind flange
-
-
H
25
FRESH CRUDE
Liquid
839
21.30
92.00
-
170.00
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
16"
CRU
011
003002
106CS1P
SA-JER-DS011-TRJR-480005
Reducer
-
-
H
40
FRESH CRUDE
Liquid
839
21.30
92.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
20"
CRU
011
003002
106CS1P
Reducer
011-E-0005
-
-
H
50
FRESH CRUDE
Liquid
839
21.30
92.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
16"
CRU
011
003002
106CS1P
Reducer
SA-JER-DS011-TRJR-480006
-
-
H
40
FRESH CRUDE
Liquid
839
21.30
92.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
16"
CRU
011
003002
106CS1P
Reducer
16"-CRU-011003002-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
839
21.30
92.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003002
106CS1P
16"-CRU-011003002-106CS1P-H
011-TT-0017
-
-
H
25
FRESH CRUDE
Liquid
839
21.30
92.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
20"
CRU
011
003003
106CS1P
011-E-0005
Reducer
-
-
H
50
FRESH CRUDE
Liquid
835
21.30
97.00
-
-
50.00
135.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
16"
CRU
011
003003
106CS1P
Reducer
SA-JER-DS011-TRJR-480007
-
-
H
50
FRESH CRUDE
Liquid
835
21.30
97.00
-
-
50.00
135.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
CRU
011
003003
106CS1P
16"-CRU-011003003-106CS1P-H
011-TT-0019
-
-
H
40
FRESH CRUDE
Liquid
835
21.30
97.00
-
-
50.00
135.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480007
16"
CRU
011
003003
106CS1P
SA-JER-DS011-TRJR-480006
Reducer
-
-
H
50
FRESH CRUDE
Liquid
835
21.30
97.00
-
-
50.00
135.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480007
16"
CRU
011
003003
106CS1P
16"-CRU-011003003-106CS1P-H
2"-CRU-011004006-106CS1P-P
-
-
H
50
FRESH CRUDE
Liquid
835
21.30
97.00
-
-
50.00
135.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480007
20"
CRU
011
003003
106CS1P
Reducer
011-E-0006
-
-
H
50
FRESH CRUDE
Liquid
835
21.30
97.00
-
-
50.00
135.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
CRU
011
003003
106CS1P
2"-FLO-011003303-101CS1P-N
Insul Brk
-
-
P
25
FRESH CRUDE
Liquid
835
21.30
97.00
-
-
50.00
135.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
3/4"
CRU
011
003003
106CS1P
2"-CRU-011003003-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
835
21.30
97.00
-
-
50.00
135.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
CRU
011
003003
106CS1P
Insul Brk
16"-CRU-011003003-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
835
21.30
97.00
-
-
50.00
135.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
CRU
011
003003
106CS1P
16"-CRU-011003003-106CS1P-H
2"-CRU-011003009-106CS1P-P
-
-
H
40
FRESH CRUDE
Liquid
835
21.30
97.00
-
-
50.00
135.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003004
106CS1P
12"-CRU-011002002-106CS1P-H
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003004
106CS1P
Insul Brk
2"-CLD-011003301-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003004
106CS1P
2"-CRU-011003004-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003005
106CS1P
12"-CRU-011002002-106CS1P-H
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003005
106CS1P
Insul Brk
2"-CLD-011003303-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003005
106CS1P
2"-CRU-011003005-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
3/4"
CRU
011
003006
106CS1P
10"-CRU-011003001-106CS1P-H
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
3/4"
CRU
011
003006
106CS1P
Insul Brk
Reducer
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
3/4"
CRU
011
003006
106CS1P 3/4"-CRU-011003006-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003006
106CS1P
Reducer
2"-CLD-011003305-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
3/4"
CRU
011
003006
106CS1P
10"-CRU-011003001-106CS1P-H
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
3/4"
CRU
011
003006
106CS1P
Insul Brk
3/4"-CRU-011003006-106CS1P-P
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
16"
CRU
011
003007
106CS1P
16"-CRU-011003002-106CS1P-H 16"-CRU-011003007-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
839
21.30
92.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
16"
CRU
011
003007
106CS1P
16"-CRU-011003007-106CS1P-H 16"-CRU-011003003-106CS1P-H
-
-
H
50
FRESH CRUDE
Liquid
839
21.30
97.00
-
-
50.00
135.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
CRU
011
003008
106CS1P
16"-CRU-011003002-106CS1P-H
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid
839
21.30
92.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
CRU
011
003008
106CS1P
Insul Brk
2"-CLD-011003309-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
839
21.30
92.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
CRU
011
003008
106CS1P
2"-CRU-011003008-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
839
21.30
92.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
CRU
011
003009
106CS1P
2"-CRU-011003003-106CS1P-H
2"-CLD-011003310-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
835
21.30
97.00
-
-
50.00
135.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
CRU
011
003009
106CS1P
2"-CRU-011003009-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
835
21.30
97.00
-
-
50.00
135.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003010
106CS1P
UC
Insul Brk
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@290º
SA-JER-DS011-TRJR-480005
3/4"
CRU
011
003010
106CS1P
2"-CRU-011003010-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@290º
SA-JER-DS011-TRJR-480005
2"
CRU
011
003010
106CS1P
Insul Brk
12"-CRU-011002002-106CS1P-H
-
-
H
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@290º
SA-JER-DS011-TRJR-480005
2"
CRU
011
003011
106CS1P
UC
Insul Brk
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
3/4"
CRU
011
003011
106CS1P
2"-CRU-011003011-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003011
106CS1P
Insul Brk
12"-CRU-011002002-106CS1P-H
-
-
H
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
CRU
011
003012
106CS1P
UC
Insul Brk
-
-
P
25
FRESH CRUDE
Liquid
835
21.30
92.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
3/4"
CRU
011
003012
106CS1P
2"-CRU-011003012-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
835
21.30
92.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
CRU
011
003012
106CS1P
Insul Brk
16"-CRU-011003002-106CS1P-H
-
-
H
25
FRESH CRUDE
Liquid
835
21.30
92.00
-
-
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003013
106CS1P
12"-CRU-011003002-106CS1P-H
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid/Gas Mixture
15.5
21.30
92.00
-
170.00
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003013
106CS1P
Insul Brk
2"-CLD-011003313-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid/Gas Mixture
15.5
21.30
92.00
-
170.00
50.00
130.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003013
106CS1P
2"-CRU-011003013-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid/Gas Mixture
15.5
21.30
92.00
-
170.00
50.00
130.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003014
106CS1P
12"-CRU-011003002-106CS1P-H
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid
839
21.30
92.00
-
170.00
50.00
130.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003014
106CS1P
Insul Brk
2"-CLD-011003314-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid/Gas Mixture
15.5
21.30
92.00
-
170.00
50.00
130.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003014
106CS1P
2"-CRU-011003014-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid/Gas Mixture
15.5
21.30
92.00
-
170.00
50.00
130.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
CRU
011
003015
106CS1P
16"-CRU-011002002-106CS1P-H
2"-CLD-011003316-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00 NFS
By Code
M OR Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
CRU
011
003016
106CS1P
16"-CRU-011003002-106CS1P-H
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
NFS 75.00
By Code
M OR Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
CRU
011
003016
106CS1P
Insul Brk
2"-CLD-011003317-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
847
22.00
80.00
-
-
50.00
115.00
-
H
75.00 NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480007
20"
CRU
011
004001
106CS1P
011-E-0006
Reducer
-
-
H
50
FRESH CRUDE
Liquid
830
20.60
104.00
-
-
50.00
140.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480007
16"
CRU
011
004001
106CS1P
Reducer
SA-JER-DS011-TRJR-480008
-
-
H
50
FRESH CRUDE
Liquid
830
20.60
104.00
-
-
50.00
140.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480007
2"
CRU
011
004001
106CS1P
16"-CRU-011004001-106CS1P-H
011-TT-0027
-
-
H
40
FRESH CRUDE
Liquid
830
20.60
104.00
-
-
50.00
140.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
16"
CRU
011
004001
106CS1P
SA-JER-DS011-TRJR-480007
Reducer
-
-
H
50
FRESH CRUDE
Liquid
830
20.60
104.00
-
-
50.00
140.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
16"
CRU
011
004001
106CS1P
16"-CRU-011004001-106CS1P-H
Reducer
-
-
H
50
FRESH CRUDE
Liquid
830
20.60
104.00
-
-
50.00
140.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
FRESH CRUDE
Liquid
DENSITY (kg/m3)
SA-JER-DS011-TRJR-380001
SA-JER-DS011-TRJR-480004
SA-JER-DS011-TRJR-380001
-
PHASE
DOC. No.
NOTE 6
Page 44 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480008
12"
CRU
011
004001
106CS1P
Reducer
Reducer
-
-
H
50
FRESH CRUDE
Liquid
830
20.60
104.00
-
-
50.00
140.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
12"
CRU
011
004001
106CS1P
Reducer
Reducer
-
-
H
50
FRESH CRUDE
Liquid
830
20.60
104.00
-
-
50.00
140.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
14"
CRU
011
004001
106CS1P
Reducer
011-E-0007-B/D
-
-
H
50
FRESH CRUDE
Liquid
830
20.60
104.00
-
-
50.00
140.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
14"
CRU
011
004001
106CS1P
Reducer
011-E-0007-D
-
-
H
50
FRESH CRUDE
Liquid
830
20.60
104.00
-
-
50.00
140.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
14"
CRU
011
004002
106CS1P
011-E-0007 A/C
Reducer
-
-
H
50
FRESH CRUDE
Liquid
810
18.20
131.70
-
-
50.00
165.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
14"
CRU
011
004002
106CS1P
011-E-0007-C
Reducer
-
-
H
50
FRESH CRUDE
Liquid
810
18.20
131.70
-
-
50.00
165.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
12"
CRU
011
004002
106CS1P
Reducer
Reducer
-
-
H
50
FRESH CRUDE
Liquid
810
18.20
131.70
-
-
50.00
165.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
12"
CRU
011
004002
106CS1P
Reducer
Reducer
-
-
H
50
FRESH CRUDE
Liquid
810
18.20
131.70
-
-
50.00
165.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480009
16"
CRU
011
004002
106CS1P
SA-JER-DS011-TRJR-480008
Reducer
-
-
H
65
FRESH CRUDE
Liquid
810
18.20
131.70
-
-
50.00
165.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480009
20"
CRU
011
004002
106CS1P
Reducer
011-E-0008
-
-
H
65
FRESH CRUDE
Liquid
810
18.20
131.70
-
-
50.00
165.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
16"
CRU
011
004002
106CS1P
Reducer
SA-JER-DS011-TRJR-480009
-
-
H
65
FRESH CRUDE
Liquid
810
18.20
131.70
-
-
50.00
165.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
2"
CRU
011
004002
106CS1P
16"-CRU-011004002-106CS1P-H
011-TT-0025
-
-
H
40
FRESH CRUDE
Liquid
810
18.20
131.70
-
-
50.00
165.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
16"
CRU
011
004002
106CS1P
Reducer
16"-CRU-011004002-106CS1P-H
-
-
H
65
FRESH CRUDE
Liquid
810
18.20
131.70
-
-
50.00
165.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
2"
CRU
011
004003
106CS1P
12"-CRU-011004001-106CS1P-H
Insul Brk
-
-
H
40
FRESH CRUDE
Liquid
830
20.60
104.00
-
-
50.00
140.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
2"
CRU
011
004003
106CS1P
Insul Brk
2"-CLD-011004304-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
830
20.60
104.00
-
-
50.00
140.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
2"
CRU
011
004003
106CS1P
2"-CRU-011004003-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
830
20.60
104.00
-
-
50.00
140.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
2"
CRU
011
004004
106CS1P
12"-CRU-011004001-106CS1P-H
Insul Brk
-
-
H
40
FRESH CRUDE
Liquid
830
20.60
104.00
-
-
50.00
140.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
2"
CRU
011
004004
106CS1P
Insul Brk
2"-CLD-011004305-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
830
20.60
104.00
-
-
50.00
140.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
2"
CRU
011
004004
106CS1P
2"-CRU-011004004-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
830
20.60
104.00
-
-
50.00
140.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480007
2"
CRU
011
004006
106CS1P
16"-CRU-011003003-106CS1P-H
2"-CLD-011004310-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
835
21.30
97.00
-
-
50.00
135.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480007
2"
CRU
011
004006
106CS1P
2"-CRU-011004006-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
835
21.30
97.00
-
-
50.00
135.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Y
POTENTIAL
N
N
N
N
-
NOTE 6
if insulated M or Q SA-JER-DS011-TRJR-480008
-
CRU
011
004601
106CS1P
TRIM
-
-
H
-
-
-
-
20.20
132.00
-
-
50.00
165.00
-
Visual Test
0.00
NFS
By Code
SA-JER-DS011-TRJR-480009
20"
CRU
011
005001
106CS1P
SA-JER-DS011-TRJR-480009
16"
CRU
011
005001
106CS1P
SA-JER-DS011-TRJR-480010
16"
CRU
011
005001
106CS1P
011-E-0008
Reducer
-
-
H
65
FRESH CRUDE
Liquid
803
17.50
140.50
-
-
50.00
170.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Reducer
SA-JER-DS011-TRJR-480010
-
-
H
65
FRESH CRUDE
Liquid
803
17.50
140.50
-
-
50.00
170.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480009
Reducer
-
-
H
65
FRESH CRUDE
Liquid
803
17.50
140.50
-
-
50.00
170.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
16"
CRU
011
005001
106CS1P
NOTE 6
16"-CRU-011005001-106CS1P-H
Reducer
-
-
H
65
FRESH CRUDE
Liquid
803
17.50
140.50
-
-
50.00
170.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
12"
CRU
011
005001
NOTE 6
106CS1P
Reducer
Reducer
-
-
H
50
FRESH CRUDE
Liquid
803
17.50
140.50
-
-
50.00
170.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
12"
CRU
011
NOTE 6
005001
106CS1P
Reducer
Reducer
-
-
H
50
FRESH CRUDE
Liquid
803
17.50
140.50
-
-
50.00
170.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
14"
CRU
NOTE 6
011
005001
106CS1P
Reducer
011-E-0009-A
-
-
H
50
FRESH CRUDE
Liquid
803
17.50
140.50
-
-
50.00
170.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
14"
CRU
011
005001
106CS1P
Reducer
011-E-0009-B
-
-
H
50
FRESH CRUDE
Liquid
803
17.50
140.50
-
-
50.00
170.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
011-E-0007
if NOT insulated B or Q
SA-JER-DS011-TRJR-480010
14"
CRU
011
005002
106CS1P
011-E-0009-A
Reducer
-
-
H
50
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
14"
CRU
011
005002
106CS1P
011-E-0009-B
Reducer
-
-
H
50
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
12"
CRU
011
005002
106CS1P
Reducer
Reducer
-
-
H
50
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
2"
CRU
011
005002
106CS1P
12"-CRU-011005002-106CS1P-H
011-TT-0498
-
-
H
40
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
12"
CRU
011
005002
106CS1P
Reducer
Reducer
-
-
H
50
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
3/4"
CRU
011
005002
106CS1P
2"-CRU-011005002-106CS1P-P
Blind flange
-
-
H
25
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
2"
CRU
011
005002
106CS1P
2"-FLO-011005302-101CS1P-N
Insul Brk
-
-
H
40
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
2"
CRU
011
005002
106CS1P
12"-CRU-011005002-106CS1P-H
Blind flange
-
-
H
40
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
2"
CRU
011
005002
106CS1P
Insul Brk
12"-CRU-011005002-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
2"
CRU
011
005002
106CS1P
12"-CRU-011005002-106CS1P-H
011-TT-0499
-
-
H
40
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
2"
CRU
011
005002
106CS1P
12"-CRU-011005002-106CS1P-H
2"-CRU-011005017-106CS1P-P
-
-
H
40
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
2"
CRU
011
005002
106CS1P
12"-CRU-011005002-106CS1P-H
Blind flange
-
-
H
40
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
2"
CRU
011
005002
106CS1P
Insul Brk
12"-CRU-011005002-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480011
18"
CRU
011
005002
106CS1P
SA-JER-DS011-TRJR-480010
Reducer
-
-
H
65
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480011
16"
CRU
011
005002
106CS1P
Reducer
16"-CRU-011006001-106CS2P-H
-
-
H
65
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480011
18"
CRU
011
005002
106CS1P
SA-JER-DS011-TRJR-480010
011-ZV-0087
-
-
H
65
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6 NOTE 6 NOTE 6; MAX. TEMPERATURE FOR THERMAL EXPANSION 294°C. NOTE 6; MAX. TEMPERATURE FOR THERMAL EXPANSION 294°C. NOTE 6; MAX. TEMPERATURE FOR THERMAL EXPANSION 294°C. NOTE 6; MAX. TEMPERATURE FOR THERMAL EXPANSION 294°C. NOTE 6; MAX. TEMPERATURE FOR THERMAL EXPANSION 294°C. NOTE 6; MAX. TEMPERATURE FOR THERMAL EXPANSION 294°C. NOTE 6; MAX. TEMPERATURE FOR THERMAL EXPANSION 294°C. NOTE 6; MAX. TEMPERATURE FOR THERMAL EXPANSION 294°C. NOTE 6; MAX. TEMPERATURE FOR THERMAL EXPANSION 294°C. NOTE 6; MAX. TEMPERATURE FOR THERMAL EXPANSION 294°C. NOTE 6; MAX. TEMPERATURE FOR THERMAL EXPANSION 294°C. NOTE 6; MAX. TEMPERATURE FOR THERMAL EXPANSION 294°C. NOTE 6; MAX. TEMPERATURE FOR THERMAL EXPANSION 294°C. NOTE 6 NOTE 6 NOTE 6 MAX.TEMPERATURE FOR THERMAL EXPANSION: 294 ºC NOTE 6 MAX.TEMPERATURE FOR THERMAL EXPANSION: 294 ºC NOTE 6 MAX.TEMPERATURE FOR THERMAL EXPANSION: 294 ºC NOTE 6 MAX.TEMPERATURE FOR THERMAL EXPANSION: 294 ºC NOTE 6 MAX.TEMPERATURE FOR THERMAL EXPANSION: 294 ºC NOTE 6 MAX.TEMPERATURE FOR THERMAL EXPANSION: 294 ºC NOTE 6
SA-JER-DS011-TRJR-480010
18"
CRU
011
005002
106CS1P
Reducer
Reducer
-
-
H
65
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
16"
CRU
011
005002
106CS1P
Reducer
16"-CRU-011005002-106CS1P-H
-
-
H
65
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
18"
CRU
011
005002
106CS1P
Reducer
18"-CRU-011005002-106CS1P-H
-
-
H
65
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
3/4"
CRU
011
005002
106CS1P
18"-CRU-011005002-106CS1P-H
011-PDT-0200
-
-
H
25
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
3/4"
CRU
011
005002
106CS1P
18"-CRU-011005002-106CS1P-H
011-PDT-0005
-
-
H
25
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
18"
CRU
011
005002
106CS1P
18"-CRU-011005002-106CS1P-H
Reducer
-
-
H
65
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
16"
CRU
011
005002
106CS1P
Reducer
Reducer
-
-
H
65
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 8
SA-JER-DS011-TRJR-480010
18"
CRU
011
005002
106CS1P
Reducer
18"-CRU-011005002-106CS1P-H
-
-
H
65
FRESH CRUDE
Liquid
801
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
18"
CRU
011
005002
106CS1P
18"-CRU-011005002-106CS1P-H
SA-JER-DS011-TRJR-480011
-
-
H
65
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
16"
CRU
011
005002
106CS1P
16"-CRU-011005002-106CS1P-H
Reducer
-
-
H
65
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
3/4"
CRU
011
005002
106CS1P
18"-CRU-011005002-106CS1P-H
011-PDT-0200
-
-
H
25
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
18"
CRU
011
005002
106CS1P
Reducer
18"-CRU-011005002-106CS1P-H
-
-
H
65
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
3/4"
CRU
011
005002
106CS1P
18"-CRU-011005002-106CS1P-H
011-PDT-0005
-
-
H
25
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
18"
CRU
011
005002
106CS1P
18"-CRU-011005002-106CS1P-H
SA-JER-DS011-TRJR-480011
-
-
H
65
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
CRU
011
005004
106CS1P
12"-CRU-011005001-106CS1P-H
Insul Brk
-
-
H
40
FRESH CRUDE
Liquid
803
17.50
140.50
-
-
50.00
170.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
CRU
011
005004
106CS1P
Insul Brk
2"-CLD-011005301-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
803
17.50
140.50
-
-
50.00
170.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
CRU
011
005004
106CS1P
2"-CRU-011005004-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
803
17.50
140.50
-
-
50.00
170.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
CRU
011
005005
106CS1P
12"-CRU-011005001-106CS1P-H
Insul Brk
-
-
H
40
FRESH CRUDE
Liquid
803
17.50
140.50
-
-
50.00
170.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
CRU
011
005005
106CS1P
Insul Brk
2"-CLD-011005302-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
803
17.50
140.50
-
-
50.00
170.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
2"
CRU
011
005005
106CS1P
2"-CRU-011005005-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
803
17.50
140.50
-
-
50.00
170.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
6"
CRU
011
005011
106CS1P
18"-CRU-011005002-106CS1P-H
6"-CRU-011005011-106CS1P-H
-
-
H
50
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6 NOTE 6 MAX. TEMPERATURE FOR THERMAL EXPANSION: 294 ºC. NOTES 6,10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 294 ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 294 ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 294 ºC. NOTE 10
SA-JER-DS011-TRJR-480010
6"
CRU
011
005011
106CS1P
6"-CRU-011005011-106CS1P-H
Reducer
-
-
H
50
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
3/4"
CRU
011
005011
106CS1P
6"-CRU-011005011-106CS1P-H
Blind flange
-
-
H
25
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
4"
CRU
011
005011
106CS1P
Reducer
011-TZV-0013
-
-
H
50
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480009
2"
CRU
011
005013
106CS1P
16"-CRU-011004002-106CS1P-H
Insul Brk
-
-
H
40
FRESH CRUDE
Liquid
810
18.20
131.70
-
-
50.00
165.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480009
2"
CRU
011
005013
106CS1P
Insul Brk
2"-CLD-011005307-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
810
18.20
131.70
-
-
50.00
165.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480009
2"
CRU
011
005013
106CS1P
2"-CRU-011005013-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
810
18.20
131.70
-
-
50.00
165.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
UC
Insul Brk
-
-
P
25
FRESH CRUDE
Liquid
803
17.50
140.50
-
-
50.00
170.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@290 ºC.
-
-
P
25
FRESH CRUDE
Liquid
803
17.50
140.50
-
-
50.00
170.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@290 ºC.
SA-JER-DS011-TRJR-480010
2"
CRU
011
005014
106CS1P
SA-JER-DS011-TRJR-480010
3/4"
CRU
011
005014
106CS1P
2"-CRU-011005014-106CS1P-P
Blind flange
SA-JER-DS011-TRJR-480010
2"
CRU
011
005014
106CS1P
Insul Brk
12"-CRU-011005001-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
803
17.50
140.50
-
-
50.00
170.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@290 ºC.
SA-JER-DS011-TRJR-480010
2"
CRU
011
005015
106CS1P
UC
Insul Brk
-
-
P
25
FRESH CRUDE
Liquid
803
17.50
140.50
-
-
50.00
170.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@290 ºC.
SA-JER-DS011-TRJR-480010
3/4"
CRU
011
005015
106CS1P
2"-CRU-011005015-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
803
17.50
140.50
-
-
50.00
170.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@290 ºC.
SA-JER-DS011-TRJR-480010
2"
CRU
011
005015
106CS1P
Insul Brk
12"-CRU-011005001-106CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
803
17.50
140.50
-
-
50.00
170.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@290 ºC.
SA-JER-DS011-TRJR-480010
2"
CRU
011
005016
106CS1P
12"-CRU-011005002-106CS1P-H
Insul Brk
-
-
H
40
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
CRU
011
005016
106CS1P
Insul Brk
2"-CLD-011005309-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
CRU
011
005016
106CS1P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
2"-CRU-011005016-106CS1P-P
Page 45 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9) CRU
011
NUMBER 005017
LINE CLASS 106CS1P
FROM
TO
TYPE
TEMP. (ºC)
2"-CRU-011005002-106CS1P-H
2"-CLD-011005310-101CH2S-P
-
-
2"-CRU-011005017-106CS1P-P
Blind flange
INSULATION (NOTE 2)
TYPE
THICKNESS (mm)
FLUID
PHASE
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
P
25
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
CRU
011
005017
106CS1P
-
-
P
25
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
16"
CRU
011
006001
106CS2P
16"-CRU-011005002-106CS1P-H 18"-CRU-011006002-106CS2P-H
-
-
H
65
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
3/4"
CRU
011
006001
106CS2P
16"-CRU-011006001-106CS2P-H
Blind flange
-
-
H
25
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
3/4"
CRU
011
006001
106CS2P
16"-CRU-011006001-106CS2P-H
Blind flange
-
-
H
25
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
18"
CRU
011
006002
106CS2P
18"-CRU-011006006-103CS2P-H
SA-JER-DS011-TRJR-480013
-
-
H
65
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
18"
CRU
011
006002
106CS2P
SA-JER-DS011-TRJR-480011
Reducer
-
-
H
65
FRESH CRUDE
Liquid
803
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
6"-PRW-011042006-106CS2P-H
18"-CRU-011006002-106CS2P-H
-
-
H
50
FRESH CRUDE
Liquid
803
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
25
803
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
UNIT
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
DOC. No.
M
SA-JER-DS011-TRJR-480013
6"
CRU
011
006002
106CS2P
SA-JER-DS011-TRJR-480013
3/4"
CRU
011
006002
106CS2P
18"-CRU-011006002-106CS2P-H
011-PDT-0006
-
FRESH CRUDE
Liquid
SA-JER-DS011-TRJR-480013
16"
CRU
011
006002
106CS2P
Reducer
16"-CRU-011006002-106CS2P-H
-
-
H
65
FRESH CRUDE
Liquid
803
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
18"
CRU
011
006002
106CS2P
18"-CRU-011006002-106CS2P-H
Reducer
-
-
H
65
FRESH CRUDE
Liquid
803
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3/4"
CRU
011
006002
106CS2P
18"-CRU-011006002-106CS2P-H
011-PDT-0201
-
-
H
25
FRESH CRUDE
Liquid
803
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
16"
CRU
011
006002
106CS2P
Reducer
Reducer
-
-
H
65
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
18"
CRU
011
006002
106CS2P
Reducer
18"-CRU-011006002-106CS2P-H
-
-
H
65
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
18"
CRU
011
006002
106CS2P
18"-CRU-011006002-106CS2P-H
SA-JER-DS011-TRJR-480012
-
-
H
65
FRESH CRUDE
Liquid
801
12.30
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
16"
CRU
011
006002
106CS2P
16"-CRU-011006002-106CS2P-H
Reducer
-
-
H
65
FRESH CRUDE
Liquid
801
12.30
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3/4"
CRU
011
006002
106CS2P
18"-CRU-011006002-106CS2P-H
011-PDT-0006
-
-
H
25
FRESH CRUDE
Liquid
801
12.30
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
18"
CRU
011
006002
106CS2P
Reducer
18"-CRU-011006002-106CS2P-H
-
-
H
65
FRESH CRUDE
Liquid
801
12.30
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3/4"
CRU
011
006002
106CS2P
18"-CRU-011006002-106CS2P-H
011-PDT-0201
-
-
H
25
FRESH CRUDE
Liquid
801
12.30
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
18"
CRU
011
006002
106CS2P
SA-JER-DS011-TRJR-480013
011-ZV-0088
-
-
H
65
FRESH CRUDE
Liquid
801
12.30
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
2"
CRU
011
006002
106CS2P
18"-CRU-011006002-106CS2P-H
Blind flange
-
-
H
40
FRESH CRUDE
Liquid
801
12.30
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
16"
CRU
011
006003
103CS1P
011-D-0001
011-SP-0020
-
-
H
65
FRESH CRUDE
Gas
-
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 200°C MAX.TEMPERATURE FOR OTHER CASEAS 148°C NOTES 6, 10
SA-JER-DS011-TRJR-480011
16"
CRU
011
006003
103CS1P
011-SP-0020
Reducer
-
-
H
65
FRESH CRUDE
Gas
-
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480011
8"
CRU
011
006003
103CS1P
Reducer
011-PZV-0001
-
-
H
50
FRESH CRUDE
Gas
-
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480011
16"
CRU
011
006003
103CS1P
16"-CRU-011006003-103CS1P-H
011-SP-0020
-
-
H
65
FRESH CRUDE
Gas
-
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480011
16"
CRU
011
006003
103CS1P
011-SP-0020
Reducer
-
-
H
65
FRESH CRUDE
Gas
-
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480011
8"
CRU
011
006003
103CS1P
Reducer
011-PZV-0002
-
-
H
50
FRESH CRUDE
Gas
-
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 200°C MAX.TEMPERATURE FOR OTHER CASEAS 148°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 200°C MAX.TEMPERATURE FOR OTHER CASEAS 148°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 200°C MAX.TEMPERATURE FOR OTHER CASEAS 148°C NOTES 6, 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 200°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 200°C MAX.TEMPERATURE FOR OTHER CASEAS 148°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 200°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 200°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 200°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 200°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 200°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 200°C NOTE 10
SA-JER-DS011-TRJR-480011
4"
CRU
011
006003
103CS1P
16"-CRU-011006003-103CS1P-H
4"-LFL-011006302-101CH2F-N
-
-
H
50
FRESH CRUDE
Gas
-
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480011
3/4"
CRU
011
006003
103CS1P
4"-CRU-011006003-103CS1P-H
Plug
-
-
H
25
FRESH CRUDE
Gas
-
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480011
3/4"
CRU
011
006003
103CS1P
16"-CRU-011006003-103CS1P-H 3/4"-LFL-011006301-101CH2F-N
-
-
H
25
FRESH CRUDE
Gas
-
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480011
3/4"
CRU
011
006003
103CS1P 3/4"-CRU-011006003-103CS1P-H
-
-
H
25
FRESH CRUDE
Gas
-
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480011
3/4"
CRU
011
006003
103CS1P
-
-
H
25
FRESH CRUDE
Gas
-
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480011
3/4"
CRU
011
006003
103CS1P 3/4"-CRU-011006003-103CS1P-H
Plug
-
-
H
25
FRESH CRUDE
Gas
-
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
3/4"
CRU
011
006005
106CS1P
18"-CRU-011005002-106CS1P-H
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
3/4"
CRU
011
006005
106CS1P
Insul Brk
Reducer
-
-
P
25
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
3/4"
CRU
011
006005
106CS1P 3/4"-CRU-011006005-106CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
CRU
011
006005
106CS1P
Reducer
2"-CLD-011006301-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
803
16.80
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
18"
CRU
011
006006
103CS2P
011-D-0001
18"-CRU-011006002-106CS2P-H
-
-
H
65
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
3"
CRU
011
006006
103CS2P
3"-CRU-011006006-103CS2P-H
18"-CRU-011006006-103CS2P-H
-
-
H
40
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
2"
CRU
011
006006
103CS2P
18"-CRU-011006006-103CS2P-H
011-TT-0274
-
-
H
40
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
3"
CRU
011
006006
103CS2P
3"-FLO-011006301-101CS1P-N
3"-CRU-011006006-103CS2P-H
-
-
H
40
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
3/4"
CRU
011
006006
103CS2P
3"-CRU-011006006-103CS2P-H
Plug
-
-
H
25
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480011
3/4"
CRU
011
006007
103CS1P
18"-CRU-011006006-103CS2P-H
011-SC-0015
-
-
P
25
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
16"-CRU-011006003-103CS1P-H 3/4"-LFL-011006301-101CH2F-N
NOTE 6
SAMPLE COOLER
-
-
H
25
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE.
011-ZV-0087
011-D-0001
-
-
H
65
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
011-SC-0015
1"-CLD-011006303-103CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
801
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
1"-CLD-011006303-103CH2S-H
-
-
P
25
FRESH CRUDE
Liquid
801
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
011-SC-0061
-
-
H
25
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
3/4"
CRU
011
006007
103CS1P
SA-JER-DS011-TRJR-480011
18"
CRU
011
006008
103CS1P
SA-JER-DS011-TRJR-480011
3/4"
CRU
011
006010
103CS1P
SA-JER-DS011-TRJR-480274
3/4"
CRU
011
006010
103CS1P 1/2"-CRU-011200001-103CS1P-N
SA-JER-DS011-TRJR-480011
3/4"
CRU
011
006011
103CS1P
SA-JER-DS011-TRJR-480274
Plug
18"-CRD-011006006-103CS1P-H
18"-CRU-011006008-103CS1P-H
SA-JER-DS011-TRJR-480274
3/4"
CRU
011
006011
103CS1P
18"-CRD-011006008-103CS1P-H
SA-JER-DS011-TRJR-480011
3/4"
CRU
011
006012
103CS1P
011-SC-0061
SA-JER-DS011-TRJR-480274
3/4"
CRU
011
006012
103CS1P 1/2"-CRU-011200003-103CS1P-N
SA-JER-DS011-TRJR-480011
3/4"
CRU
011
006013
103CS2P
SA-JER-DS011-TRJR-480011
3/4"
CRU
011
SA-JER-DS011-TRJR-480011
3/4"
CRU
SA-JER-DS011-TRJR-480011
3/4"
CRU
SA-JER-DS011-TRJR-480011
3/4"
SA-JER-DS011-TRJR-480011
NOTE 6
SAMPLE COOLER
-
-
H
25
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE.NOTE 6.
1"-CLD-011006303-103CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
801
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
1"-CLD-011006303-103CH2S-H
-
-
P
25
FRESH CRUDE
Liquid
801
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
3/4"-CRU-011006013-103CS2P-H
-
-
H
25
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
006013
103CS2P 3/4"-CRU-011006013-103CS2P-H 3/4"-CLD-011006311-103CH2S-H
-
-
H
25
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
011
006013
103CS2P
3/4"-CRU-011006013-103CS2P-H
-
-
H
25
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
011
006013
103CS2P 3/4"-CRU-011006013-103CS2P-H 3/4"-CLD-011006311-103CH2S-H
-
-
H
25
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
CRU
011
006013
103CS2P
18"-CRU-011006006-103CS2P-H
-
-
H
25
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
3/4"
CRU
011
006013
103CS2P 3/4"-CRU-011006013-103CS2P-H 3/4"-CLD-011006311-103CH2S-H
-
-
H
25
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
3/4"
CRU
011
006014
103CS1P
3/4"-LFL-011006303-101CH2F-N
-
-
P
25
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
3/4"
CRU
011
006014
103CS1P 3/4"-CRU-011006014-103CS1P-P
Plug
-
-
P
25
FRESH CRUDE
Liquid
801
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
2"
CRU
011
006601
103CS1P
011-D-0001
011-LG-0149
-
-
H
40
-
-
-
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
SA-JER-DS011-TRJR-480011
2"
CRU
011
006601
103CS1P
011-D-0001
011-PT-0373-C
-
-
H
40
-
-
-
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
SA-JER-DS011-TRJR-480011
6"
CRU
011
006601
103CS1P
011-D-0001
Blind flange
-
-
H
50
-
-
-
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
SA-JER-DS011-TRJR-480011
2"
CRU
011
006601
103CS1P
011-D-0001
011-PT-0373-A
-
-
H
40
-
-
-
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
SA-JER-DS011-TRJR-480011
2"
CRU
011
006601
103CS1P
011-D-0001
011-PT-0373-B
-
-
H
40
-
-
-
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
SA-JER-DS011-TRJR-480011
2"
CRU
011
006601
103CS1P
011-D-0001
011-LG-0149
-
-
H
40
-
-
-
13.50
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
SA-JER-DS011-TRJR-480012
18"
CRU
011
007002
103CS1P
011-D-0002
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
801
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
24"
CRU
011
007002
103CS1P
Reducer
SA-JER-DS011-TRJR-480015
-
-
H
65
DESALTED CRUDE
Liquid
801
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
3"
CRU
011
007002
103CS1P
3"-CRU-011007002-103CS1P-H
24"-CRU-011007002-103CS1P-H
-
-
H
40
DESALTED CRUDE
Liquid
801
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
3"
CRU
011
007002
103CS1P
3"-FLO-011007301-101CS1P-N
3"-CRU-011007002-103CS1P-H
-
-
H
40
DESALTED CRUDE
Liquid
801
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
2"
CRU
011
007002
103CS1P
24"-CRU-011007002-103CS1P-H
Blind flange
-
-
H
40
DESALTED CRUDE
Liquid
801
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
16"
CRU
011
007002
103CS1P
16"-CRU-011007006-106CS2P-H 24"-CRU-011007002-103CS1P-H
-
-
H
65
DESALTED CRUDE
Liquid
801
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
3/4"
CRU
011
007002
103CS1P
3"-CRU-011007002-103CS1P-H
Plug
-
-
H
25
DESALTED CRUDE
Liquid
801
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
24"
CRU
011
007002
103CS1P
SA-JER-DS011-TRJR-480012
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
2"
CRU
011
007002
103CS1P
24"-CRU-011007002-103CS1P-H
Blind flange
-
-
H
40
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
007002
103CS1P
24"-CRU-011007002-103CS1P-H
011-PI-0325
-
-
H
25
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
007002
103CS1P
24"-CRU-011007002-103CS1P-H
011-PT-0007
-
-
H
25
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
2"
CRU
011
007002
103CS1P
24"-CRU-011007002-103CS1P-H
Blind flange
-
-
H
40
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
20"
CRU
011
007002
103CS1P
Reducer
20"-CRU-011008011-103CS1P-H
-
-
H
65
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
24"
CRU
011
007002
103CS1P
24"-CRU-011007002-103CS1P-H
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
20"
CRU
011
007002
103CS1P
Reducer
20"-CRU-011008012-103CS1P-H
-
-
H
65
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3/4"
CRU
011
007004
106CS2P
18"-CRU-011006002-106CS2P-H
Insul Brk
-
-
H
25
FRESH CRUDE
Liquid
803
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3/4"
CRU
011
007004
106CS2P
Insul Brk
Reducer
-
-
P
25
FRESH CRUDE
Liquid
803
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3/4"
CRU
011
007004
106CS2P 3/4"-CRU-011007004-106CS2P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
803
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
2"
CRU
011
007004
106CS2P
Reducer
2"-CLD-011007301-101CH2S-P
-
-
P
25
FRESH CRUDE
Liquid
803
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
3/4"
CRU
011
007005
103CS1P
18"-CRU-011007002-103CS1P-H
011-SC-0016
-
-
H
25
DESALTED CRUDE
Liquid
801
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
011-D-0001
011-D-0001
011-D-0001
011-LG-0149
Page 46 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
SAMPLE COOLER
-
-
H
25
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
DESALTED CRUDE
Liquid
801
12.00
145.00
-
-
16.00
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE.
(NOTE 7)
SA-JER-DS011-TRJR-480274
3/4"
CRU
011
007005
103CS1P
18"-CRD-011007002-103CS1P-H
SA-JER-DS011-TRJR-480013
16"
CRU
011
007006
106CS2P
18"-CRU-011006002-106CS2P-H
SA-JER-DS011-TRJR-480012
-
-
H
65
FRESH CRUDE
Liquid
803
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
16"
CRU
011
007006
106CS2P
SA-JER-DS011-TRJR-480013
16"-CRU-011007002-103CS1P-H
-
-
H
65
FRESH CRUDE
Liquid
803
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
3/4"
CRU
011
007006
106CS2P
16"-CRU-011007006-106CS2P-H
Blind flange
-
-
H
25
FRESH CRUDE
Liquid
803
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
3/4"
CRU
011
007006
106CS2P
16"-CRU-011007006-106CS2P-H
Blind flange
-
-
H
25
FRESH CRUDE
Liquid
803
13.50
148.00
-
-
50.00
185.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
3/4"
CRU
011
007010
103CS1P
011-SC-0016
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
CRU
011
007010
103CS1P 1/2"-CRU-011200002-103CS1P-N
SA-JER-DS011-TRJR-480012
16"
CRU
011
007012
103CS1P
011-D-0002
SA-JER-DS011-TRJR-480012
16"
CRU
011
007012
103CS1P
SA-JER-DS011-TRJR-480012
8"
CRU
011
007012
103CS1P
SA-JER-DS011-TRJR-480012
16"
CRU
011
007012
SA-JER-DS011-TRJR-480012
16"
CRU
011
007012
SA-JER-DS011-TRJR-480012
8"
CRU
011
SA-JER-DS011-TRJR-480012
4"
CRU
SA-JER-DS011-TRJR-480012
3/4"
SA-JER-DS011-TRJR-480012 SA-JER-DS011-TRJR-480012
1"-CLD-011007305-103CH2S-P
-
-
P
25
DESALTED CRUDE
Liquid
801
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
1"-CLD-011007305-103CH2S-H
-
-
P
25
DESALTED CRUDE
Liquid
801
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
011-SP-0021
-
-
H
65
FRESH CRUDE
Gas
-
12.00
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 145 ºC.MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC. NOTES 6,10
011-SP-0021
Reducer
-
-
H
65
FRESH CRUDE
Gas
-
12.00
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
Reducer
011-PZV-0003
-
-
H
50
FRESH CRUDE
Gas
-
12.00
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
103CS1P
16"-CRU-011007012-103CS1P-H
011-SP-0021
-
-
H
65
FRESH CRUDE
Gas
-
12.00
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
103CS1P
011-SP-0021
Reducer
-
-
H
65
FRESH CRUDE
Gas
-
12.00
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
007012
103CS1P
Reducer
011-PZV-0004
-
-
H
50
FRESH CRUDE
Gas
-
12.00
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
011
007012
103CS1P
16"-CRU-011007012-103CS1P-H
4"-LFL-011007302-101CH2F-N
-
-
H
50
FRESH CRUDE
Gas
-
12.00
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 145 ºC.MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC. NOTES 6,10
CRU
011
007012
103CS1P
4"-CRU-011007012-103CS1P-H
Plug
-
-
H
25
FRESH CRUDE
Gas
-
12.00
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 145 ºC.MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC. NOTES 6,10
3/4"
CRU
011
007012
103CS1P
16"-CRU-011007012-103CS1P-H 3/4"-LFL-011007301-101CH2F-N
-
-
H
25
FRESH CRUDE
Gas
-
12.00
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
3/4"
CRU
011
007012
103CS1P 3/4"-CRU-011007012-103CS1P-H
-
-
H
25
FRESH CRUDE
Gas
-
12.00
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480012
3/4"
CRU
011
007012
103CS1P
SA-JER-DS011-TRJR-480012
3/4"
CRU
011
007012
103CS1P 3/4"-CRU-011007012-103CS1P-H
SA-JER-DS011-TRJR-480012
3/4"
CRU
011
007015
103CS1P
SA-JER-DS011-TRJR-480012
3/4"
CRU
011
SA-JER-DS011-TRJR-480012
3/4"
CRU
SA-JER-DS011-TRJR-480012
3/4"
SA-JER-DS011-TRJR-480012
3/4"
SA-JER-DS011-TRJR-480012
Plug
MAX. TEMPERATURE FOR OTHER CASES: 145 ºC. MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC. NOTE 10 MAX. TEMPERATURE FOR OTHER CASES: 145 ºC. MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC. NOTE 10 MAX. TEMPERATURE FOR OTHER CASES: 145 ºC.MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC. NOTES 6,10 MAX. TEMPERATURE FOR OTHER CASES: 145 ºC. MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC. NOTE 10 MAX. TEMPERATURE FOR OTHER CASES: 145 ºC. MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC. NOTE 10
MAX. TEMPERATURE FOR OTHER CASES: 145 ºC. MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC. NOTE 10 MAX. TEMPERATURE FOR OTHER CASES: 145 ºC. MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC. NOTE 10 MAX. TEMPERATURE FOR OTHER CASES: 145 ºC. MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC. NOTE 10 MAX. TEMPERATURE FOR OTHER CASES: 145 ºC. MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC. NOTE 10
-
-
H
25
FRESH CRUDE
Gas
-
12.00
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
Plug
-
-
H
25
FRESH CRUDE
Gas
-
12.00
148.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
3/4"-CRU-011007015-103CS1P-H
-
-
H
25
DESALTED CRUDE
Liquid
801
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
007015
103CS1P 3/4"-CRU-011007015-103CS1P-H 3/4"-CLD-011007311-103CH2S-H
-
-
H
25
DESALTED CRUDE
Liquid
801
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
011
007015
103CS1P
3/4"-CRU-011007015-103CS1P-H
-
-
H
25
DESALTED CRUDE
Liquid
801
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
CRU
011
007015
103CS1P 3/4"-CRU-011007015-103CS1P-H 3/4"-CLD-011007311-103CH2S-H
-
-
H
25
DESALTED CRUDE
Liquid
801
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
CRU
011
007015
103CS1P
18"-CRU-011007002-103CS1P-H
-
-
H
25
DESALTED CRUDE
Liquid
801
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
3/4"
CRU
011
007015
103CS1P 3/4"-CRU-011007015-103CS1P-H 3/4"-CLD-011007311-103CH2S-H
-
-
H
25
DESALTED CRUDE
Liquid
801
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
3/4"
CRU
011
007017
103CS2P
011-SC-0062
-
-
H
25
FRESH CRUDE
Liquid
801
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
CRU
011
007017
103CS1P 3/4"-CRD-011006015-103CS1P-H
SAMPLE COOLER
-
-
H
25
FRESH CRUDE
Liquid
801
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE.
SA-JER-DS011-TRJR-480012
3/4"
007018
103CS1P
Liquid
922
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
CRU
011
007018
103CS1P 1/2"-CRU-011200004-103CS1P-N
1"-CLD-011007305-103CH2S-H
-
-
P
25
FRESH CRUDE
Liquid
922
0.50
170.00
-
-
16.00
178.00
-
H
24.00
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
18"
CRU
011
007019
103CS2P
011-ZV-0088
011-D-0002
-
-
H
65
FRESH CRUDE
Liquid
801
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
3/4"
CRU
011
007020
103CS1P
011-LG-0159
3/4"-LFL-011007303-101CH2F-N
-
-
P
25
FUEL GAS
Gas
-
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
3/4"
CRU
011
007020
103CS1P 3/4"-CRU-011007020-103CS1P-P
Plug
-
-
P
25
FUEL GAS
Gas
-
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
CRU
011
16"-CRU-011007012-103CS1P-H 3/4"-LFL-011007301-101CH2F-N
011-D-0002
011-D-0002
011-D-0002
18"-CRU-011007019-103CS2P-H
011-SC-0062
1"-CLD-011007305-103CH2S-P
-
-
P
25
FRESH CRUDE
YES
Q
if insulated M or Q SA-JER-DS011-TRJR-480012
-
CRU
011
007601
103CS1P
011-D-0002
TRIM
-
-
H
-
-
-
-
12.00
145.00
-
-
16.00
178.00
-
Visual Test
0.00
NFS
By Code
SA-JER-DS011-TRJR-480012
2"
CRU
011
007601
103CS1P
011-D-0002
011-PT-0450-B
-
-
H
40
-
-
-
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
SA-JER-DS011-TRJR-480012
2"
CRU
011
007601
103CS1P
011-LG-0159
011-D-0002
-
-
H
40
-
-
-
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
SA-JER-DS011-TRJR-480012
2"
CRU
011
007601
103CS1P
011-LG-0159
011-D-0002
-
-
H
40
-
-
-
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
SA-JER-DS011-TRJR-480012
2"
CRU
011
007601
103CS1P
011-D-0002
011-PT-0450-C
-
-
H
40
-
-
-
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
SA-JER-DS011-TRJR-480012
2"
CRU
011
007601
103CS1P
011-D-0002
011-PT-0450-A
-
-
H
40
-
-
-
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
SA-JER-DS011-TRJR-480015
12"
CRU
011
008001
103CS1P
011-G-0002-A
Reducer
-
-
H
50
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
16"
CRU
011
008001
103CS1P
Reducer
16"-CRU-011008001-103CS1P-H
-
-
H
65
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008001
103CS1P
16"-CRU-011008001-103CS1P-H
011-PI-0008
-
-
H
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
16"
CRU
011
008001
103CS1P
SA-JER-DS011-TRJR-480015
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
16"-CRU-011008001-103CS1P-H
011-TT-0208
-
-
H
40
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
65
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
SA-JER-DS011-TRJR-480016
2"
CRU
011
008001
103CS1P
SA-JER-DS011-TRJR-480016
20"
CRU
011
008001
103CS1P
Reducer
011-E-0010-B
-
DESALTED CRUDE
Liquid
SA-JER-DS011-TRJR-480015
16"
CRU
011
008001
103CS1P
16"-CRU-011008001-103CS1P-H
SA-JER-DS011-TRJR-480016
-
-
H
65
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
1/2"
CRU
011
008001
103CS1P
011-FE-0061
011-FT-0061-B
-
-
H
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
1/2"
CRU
011
008001
103CS1P
011-FE-0061
011-FT-0061-A
-
-
H
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
1/2"
CRU
011
008001
103CS1P
011-FE-0061
011-FT-0061-A
-
-
H
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
1/2"
CRU
011
008001
103CS1P
011-FE-0061
011-FT-0061-B
-
-
H
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008001
103CS1P
16"-CRU-011008001-103CS1P-H
011-PT-0010
-
-
H
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
10"
CRU
011
008002
103CS1P
16"-CRU-011008001-103CS1P-H
Reducer
-
-
H
50
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
8"
CRU
011
008002
103CS1P
Reducer
Reducer
-
-
H
50
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
10"
CRU
011
008002
103CS1P
Reducer
10"-CRU-011008002-103CS1P-H
-
-
H
50
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
10"
CRU
011
008002
103CS1P
10"-CRU-011008002-103CS1P-H 24"-CRU-011007002-103CS1P-H
-
-
H
50
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
20"
CRU
011
008003
103CS1P
011-E-0010-A
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
16"
CRU
011
008003
103CS1P
Reducer
SA-JER-DS011-TRJR-480017
-
-
H
65
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
3/4"
CRU
011
008003
103CS1P
2"-CRU-011008003-103CS1P-P
Plug
-
-
H
40
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
2"
CRU
011
008003
103CS1P
16"-CRU-011008003-103CS1P-H
Blind flange
-
-
H
40
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
2"
CRU
011
008003
103CS1P
16"-CRU-011008003-103CS1P-H
011-TT-0035
-
-
H
40
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
2"
CRU
011
008003
103CS1P
Insul Brk
16"-CRU-011008003-103CS1P-H
-
-
H
40
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
2"
CRU
011
008003
103CS1P
16"-CRU-011008003-103CS1P-H
011-TT-0243
-
-
H
40
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
2"
CRU
011
008003
103CS1P
2"-FLO-011008303-101CS1P-N
Insul Brk
-
-
H
40
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
16"
CRU
011
008003
103CS1P
SA-JER-DS011-TRJR-480016
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
12"
CRU
011
008003
103CS1P
Reducer
12"-CRU-011008003-103CS1P-H
-
-
H
65
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
1/2"
CRU
011
008003
103CS1P
011-FT-0110
011-FE-0010
-
-
H
25
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
1/2"
CRU
011
008003
103CS1P
011-FT-0110
011-FE-0010
-
-
H
25
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
10"
CRU
011
008003
103CS1P
Reducer
10"-CRU-011008003-103CS1P-H
-
-
H
65
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 47 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480017
12"
CRU
011
008003
103CS1P
12"-CRU-011008003-103CS1P-H
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
12"
CRU
011
008003
103CS1P
12"-CRU-011008003-103CS1P-H
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
800
31.50
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
10"
CRU
011
008003
103CS1P
10"-CRU-011008003-103CS1P-H
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
800
31.50
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
12"
CRU
011
008003
103CS1P
Reducer
12"-CRU-011008003-103CS1P-H
-
-
H
65
DESALTED CRUDE
Liquid
800
31.50
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
14"
CRU
011
008003
103CS1P
Reducer
011-E-0011-B
-
-
H
65
DESALTED CRUDE
Liquid
800
31.50
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
16"
CRU
011
008003
103CS1P
16"-CRU-011008003-103CS1P-H
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
12"
CRU
011
008003
103CS1P
Reducer
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Reducer
8"-CRU-011008003-103CS1P-H
-
-
H
65
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
65
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
8"
CRU
011
008003
103CS1P
SA-JER-DS011-TRJR-480017
12"
CRU
011
008003
103CS1P
12"-CRU-011008003-103CS1P-H
Reducer
-
DESALTED CRUDE
Liquid
SA-JER-DS011-TRJR-480017
1/2"
CRU
011
008003
103CS1P
011-FT-0109
011-FE-0109
-
-
H
25
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
1/2"
CRU
011
008003
103CS1P
011-FT-0109
011-FE-0109
-
-
H
25
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
10"
CRU
011
008003
103CS1P
Reducer
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
12"
CRU
011
008003
103CS1P
Reducer
12"-CRU-011008003-103CS1P-H
-
-
H
65
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
12"
CRU
011
008003
103CS1P
12"-CRU-011008003-103CS1P-H
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
800
31.50
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
8"-CRU-011008003-103CS1P-H
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
800
31.50
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
65
800
31.50
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
8"
CRU
011
008003
103CS1P
SA-JER-DS011-TRJR-480017
12"
CRU
011
008003
103CS1P
Reducer
12"-CRU-011008003-103CS1P-H
-
DESALTED CRUDE
Liquid
SA-JER-DS011-TRJR-480017
14"
CRU
011
008003
103CS1P
Reducer
011-E-0012-B
-
-
H
65
DESALTED CRUDE
Liquid
800
31.50
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
2"
CRU
011
008008
103CS1P
16"-CRU-011008001-103CS1P-H
Insul Brk
-
-
H
40
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
2"
CRU
011
008008
103CS1P
Insul Brk
2"-CLD-011008303-101CH2S-P
-
-
P
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008008
103CS1P
2"-CRU-011008008-103CS1P-P
3/4"-OLW-011008301-101CS1PN
-
-
P
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008008
103CS1P
20"-CRU-011008011-103CS1P-H
Insul Brk
-
-
H
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008008
103CS1P
Insul Brk
2"-CRU-011008008-103CS1P-P
-
-
P
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
2"
CRU
011
008008
103CS1P
16"-CRU-011008011-103CS1P-H
2"-CRU-011008008-103CS1P-P
-
-
P
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
2"
CRU
011
008008
103CS1P
2"-CRU-011008008-103CS1P-P
2"-CRU-011008008-103CS1P-P
-
-
P
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008008
103CS1P
011-G-0002-A
2"-CRU-011008008-103CS1P-P
-
-
P
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008008
103CS1P
16"-CRU-011008001-103CS1P-H
2"-CRU-011008008-103CS1P-P
-
-
P
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
2"
CRU
011
008009
103CS1P
16"-CRU-011008013-103CS1P-H
Insul Brk
-
-
H
40
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
2"
CRU
011
008009
103CS1P
Insul Brk
2"-CLD-011008304-101CH2S-P
-
-
P
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008009
103CS1P
2"-CRU-011008009-103CS1P-P
3/4"-OLW-011008302-101CS1PN
-
-
P
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008009
103CS1P
20"-CRU-011008012-103CS1P-H
Insul Brk
-
-
H
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008009
103CS1P
Insul Brk
2"-CRU-011008009-103CS1P-P
-
-
P
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
2"
CRU
011
008009
103CS1P
16"-CRU-011008012-103CS1P-H
2"-CRU-011008009-103CS1P-P
-
-
P
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
2"
CRU
011
008009
103CS1P
2"-CRU-011008009-103CS1P-P
2"-CRU-011008009-103CS1P-P
-
-
P
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008009
103CS1P
011-G-0002-B
2"-CRU-011008009-103CS1P-P
-
-
P
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008009
103CS1P
16"-CRU-011008013-103CS1P-H
2"-CRU-011008009-103CS1P-P
-
-
P
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
2"
CRU
011
008010
103CS1P
16"-CRU-011008001-103CS1P-H
Insul Brk
-
-
H
40
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
2"
CRU
011
008010
103CS1P
Insul Brk
2"-CLD-011008305-101CH2S-P
-
-
P
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
2"
CRU
011
008010
103CS1P
2"-CRU-011008010-103CS1P-P
Blind flange
-
-
P
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
20"
CRU
011
008011
103CS1P
20"-CRU-011007002-103CS1P-H
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008011
103CS1P
2"-CRU-011008011-103CS1P-P
Plug
-
-
H
25
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008011
103CS1P
20"-CRU-011008011-103CS1P-H
011-PDT-0122
-
-
H
25
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
2"
CRU
011
008011
103CS1P
20"-CRU-011008011-103CS1P-H
UC
-
-
H
40
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
2"
CRU
011
008011
103CS1P
2"-FLO-011008301-101CS1P-N
Insul Brk
-
-
H
40
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008011
103CS1P
20"-CRU-011008011-103CS1P-H
011-PDT-0122
-
-
H
25
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
2"
CRU
011
008011
103CS1P
Insul Brk
20"-CRU-011008011-103CS1P-H
-
-
H
40
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
16"
CRU
011
008011
103CS1P
Reducer
011-G-0002-A
-
-
H
65
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
20"
CRU
011
008012
103CS1P
20"-CRU-011007002-103CS1P-H
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008012
103CS1P
20"-CRU-011008012-103CS1P-H
011-PDT-0127
-
-
H
25
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
2"
CRU
011
008012
103CS1P
Insul Brk
20"-CRU-011008012-103CS1P-H
-
-
H
40
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
2"
CRU
011
008012
103CS1P
2"-FLO-011008302-101CS1P-N
Insul Brk
-
-
H
40
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
2"
CRU
011
008012
103CS1P
20"-CRU-011008012-103CS1P-H
UC
-
-
H
40
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008012
103CS1P
20"-CRU-011008012-103CS1P-H
011-PDT-0127
-
-
H
25
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008012
103CS1P
2"-CRU-011008012-103CS1P-P
Plug
-
-
H
25
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
16"
CRU
011
008012
103CS1P
Reducer
011-G-0002-B
-
-
H
65
DESALTED CRUDE
Liquid
800
12.00
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
12"
CRU
011
008013
103CS1P
011-G-0002-B
Reducer
-
-
H
50
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
16"
CRU
011
008013
103CS1P
Reducer
16"-CRU-011008013-103CS1P-H
-
-
H
65
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008013
103CS1P
16"-CRU-011008013-103CS1P-H
011-PI-0009
-
-
H
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
16"
CRU
011
008013
103CS1P
16"-CRU-011008013-103CS1P-H 16"-CRU-011008001-103CS1P-H
-
-
H
65
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
14"
CRU
011
008015
103CS1P
16"-CRU-011008001-103CS1P-H
Reducer
-
-
H
50
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
16"
CRU
011
008015
103CS1P
Reducer
16"-CRU-011008003-103CS1P-H
-
-
H
65
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
2"
CRU
011
008018
103CS1P
UC
Insul Brk
-
-
P
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@290ºC.
SA-JER-DS011-TRJR-480016
3/4"
CRU
011
008018
103CS1P
2"-CRU-011008018-103CS1P-P
Plug
-
-
P
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@290ºC.
SA-JER-DS011-TRJR-480016
2"
CRU
011
008018
103CS1P
Insul Brk
16"-CRU-011008001-103CS1P-H
-
-
H
40
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@290ºC.
SA-JER-DS011-TRJR-480016
2"
CRU
011
008020
103CS1P
16"-CRU-011008003-103CS1P-H
Insul Brk
-
-
H
40
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
2"
CRU
011
008020
103CS1P
Insul Brk
2"-CLD-011008308-101CH2S-P
-
-
P
25
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
2"
CRU
011
008020
103CS1P
2"-CRU-011008020-103CS1P-P
Blind flange
-
-
P
25
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008021
103CS1P
10"-CRU-011008002-103CS1P-H
Insul Brk
-
-
H
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008021
103CS1P
Insul Brk
Reducer
-
-
P
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
3/4"
CRU
011
008021
103CS1P 3/4"-CRU-011008021-103CS1P-P
Plug
-
-
P
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
2"
CRU
011
008021
103CS1P
2"-CLD-011008309-101CH2S-P
-
-
P
25
DESALTED CRUDE
Liquid
800
33.90
145.00
-
-
42.70
180.00
-
H
64.05
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Reducer
if insulated N or Q SA-JER-DS011-TRJR-480016
-
CRU
011
008601
106CS1P
011-E-0010-A/B
TRIM
-
-
H
-
-
-
-
33.20
156.00
-
-
43.00
210.00
-
Visual Test
0.00
NFS
By Code
SA-JER-DS011-TRJR-480017
14"
CRU
011
009001
103CS1P
011-E-0011-A
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
780
29.70
168.00
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
12"
CRU
011
009001
103CS1P
Reducer
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
780
29.70
168.00
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
if NOT insulated B or Q
SA-JER-DS011-TRJR-480017
2"
CRU
011
009001
103CS1P
12"-CRU-011009001-103CS1P-H
011-TT-0042
-
-
H
40
DESALTED CRUDE
Liquid
780
29.70
168.00
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480018
16"
CRU
011
009001
103CS1P
SA-JER-DS011-TRJR-480017
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
780
29.70
168.00
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480018
20"
CRU
011
009001
103CS1P
Reducer
011-E-0013
-
-
H
65
DESALTED CRUDE
Liquid
780
29.70
168.00
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
16"
CRU
011
009001
103CS1P
Reducer
SA-JER-DS011-TRJR-480018
-
-
H
65
DESALTED CRUDE
Liquid
780
29.70
168.00
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
2"
CRU
011
009001
103CS1P
16"-CRU-011009001-103CS1P-H
011-TT-0284
-
-
H
40
DESALTED CRUDE
Liquid
780
29.70
168.00
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
14"
CRU
011
009001
103CS1P
011-E-0012-A
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
780
29.70
168.00
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
12"
CRU
011
009001
103CS1P
Reducer
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
780
29.70
168.00
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
2"
CRU
011
009001
103CS1P
12"-CRU-011009001-103CS1P-H
011-TT-0044
-
-
H
40
DESALTED CRUDE
Liquid
780
29.70
168.00
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
16"
CRU
011
009001
103CS1P
Reducer
16"-CRU-011009001-103CS1P-H
-
-
H
65
DESALTED CRUDE
Liquid
780
29.70
168.00
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
3/4"
CRU
011
009002
103CS1P
12"-CRU-011008003-103CS1P-H
Insul Brk
-
-
H
40
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
3/4"
CRU
011
009002
103CS1P
Insul Brk
Reducer
-
-
P
25
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
3/4"
CRU
011
009002
103CS1P 3/4"-CRU-011009002-103CS1P-P
Plug
-
-
P
25
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
2"
CRU
011
009002
103CS1P
Reducer
2"-CLD-011009301-101CH2S-P
-
-
P
25
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
3/4"
CRU
011
009003
103CS1P
12"-CRU-011008003-103CS1P-H
Insul Brk
-
-
H
40
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
3/4"
CRU
011
009003
103CS1P
Insul Brk
Reducer
-
-
P
25
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 48 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
INSULATION (NOTE 2)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480017
3/4"
CRU
011
009003
103CS1P 3/4"-CRU-011009003-103CS1P-P
Plug
-
-
P
25
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
2"
CRU
011
009003
103CS1P
Reducer
2"-CLD-011009307-101CH2S-P
-
-
P
25
DESALTED CRUDE
Liquid
800
32.00
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
2"
CRU
011
009004
103CS1P
12"-CRU-011008003-103CS1P-H
Insul Brk
-
-
H
40
DESALTED CRUDE
Liquid
800
31.50
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
2"
CRU
011
009004
103CS1P
Insul Brk
2"-CLD-011009304-101CH2S-P
-
-
P
25
DESALTED CRUDE
Liquid
800
31.50
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
2"
CRU
011
009004
103CS1P
2"-CRU-011009004-103CS1P-P
Blind flange
-
-
P
25
DESALTED CRUDE
Liquid
800
31.50
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
2"
CRU
011
009005
103CS1P
12"-CRU-011008003-103CS1P-H
Insul Brk
-
-
H
40
DESALTED CRUDE
Liquid
800
31.50
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
2"
CRU
011
009005
103CS1P
Insul Brk
2"-CLD-011009306-101CH2S-P
-
-
P
25
DESALTED CRUDE
Liquid
800
31.50
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
2"
CRU
011
009005
103CS1P
2"-CRU-011009005-103CS1P-P
Blind flange
-
-
P
25
DESALTED CRUDE
Liquid
800
31.50
156.40
-
-
42.70
210.00
-
H
64.41
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Y
POTENTIAL
N
N
N
N
-
NOTE 6
if insulated N or Q SA-JER-DS011-TRJR-480017
-
CRU
011
009601
106CS1P
011-E-0011-A/B
TRIM
-
-
H
-
-
-
-
30.60
170.00
-
-
43.00
200.00
-
Visual Test
0.00
NFS
By Code
SA-JER-DS011-TRJR-480017
-
CRU
011
009602
106CS1P
011-E-0012-A/B
TRIM
-
-
H
-
-
-
-
30.10
176.50
-
-
43.00
205.00
-
Visual Test
0.00
NFS
By Code
SA-JER-DS011-TRJR-480018
20"
CRU
011
010001
103CS1P
011-E-0013
Reducer
-
-
H
100
DESALTED CRUDE
Liquid
770
28.50
179.30
-
-
42.70
215.00
-
H
64.73
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480018
16"
CRU
011
010001
103CS1P
Reducer
SA-JER-DS011-TRJR-480019
-
-
H
100
DESALTED CRUDE
Liquid
770
28.50
179.30
-
-
42.70
215.00
-
H
64.73
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480018
2"
CRU
011
010001
103CS1P
16"-CRU-011010001-103CS1P-H
011-TT-0048
-
-
H
50
DESALTED CRUDE
Liquid
770
28.50
179.30
-
-
42.70
215.00
-
H
64.73
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
16"
CRU
011
010001
103CS1P
SA-JER-DS011-TRJR-480018
Reducer
-
-
H
100
DESALTED CRUDE
Liquid
770
28.50
179.30
-
-
42.70
215.00
-
H
64.73
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
16"
CRU
011
010001
103CS1P
16"-CRU-011010001-103CS1P-H
Reducer
-
-
H
100
DESALTED CRUDE
Liquid
770
28.50
179.30
-
-
42.70
215.00
-
H
64.73
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
12"
CRU
011
010001
103CS1P
Reducer
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
770
28.50
179.30
-
-
42.70
215.00
-
H
64.73
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
12"
CRU
011
010001
103CS1P
Reducer
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
770
28.50
179.30
-
-
42.70
215.00
-
H
64.73
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
14"
CRU
011
010001
103CS1P
Reducer
011-E-0014-C
-
-
H
65
DESALTED CRUDE
Liquid
770
28.50
179.30
-
-
42.70
215.00
-
H
64.73
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
14"
CRU
011
010001
103CS1P
Reducer
011-E-0014-F
-
-
H
65
DESALTED CRUDE
Liquid
770
28.50
179.30
-
-
42.70
215.00
-
H
64.73
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
14"
CRU
011
010002
103CS1P
011-E-0014-C
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
770
28.20
187.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
12"
CRU
011
010002
103CS1P
Reducer
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
770
28.20
187.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
2"
CRU
011
010002
103CS1P
12"-CRU-011010002-103CS1P-H
011-TI-0055
-
-
H
50
DESALTED CRUDE
Liquid
770
28.20
187.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
14"
CRU
011
010002
103CS1P
Reducer
011-E-0014-B
-
-
H
65
DESALTED CRUDE
Liquid
770
28.20
187.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
14"
CRU
011
010003
103CS1P
011-E-0014-F
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
770
28.20
187.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
12"
CRU
011
010003
103CS1P
Reducer
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
770
28.20
187.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
2"
CRU
011
010003
103CS1P
12"-CRU-011010003-103CS1P-H
011-TI-0056
-
-
H
50
DESALTED CRUDE
Liquid
770
28.20
187.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480019
14"
CRU
011
010003
103CS1P
Reducer
011-E-0014-E
-
-
H
65
DESALTED CRUDE
Liquid
770
28.20
187.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
16"
CRU
011
010005
101CH2S
16"-CRU-011010006-103CS1P-H
Reducer
-
-
H
100
DESALTED CRUDE
Liquid
111
4.30
200.00
-
-
7.50
278.00
-
H
12.24
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTES 6, 7
SA-JER-DS011-TRJR-480019
16"
CRU
011
010005
101CH2S
Reducer
16"-CRU-011010005-101CH2S-H
-
-
H
100
DESALTED CRUDE
Liquid
111
4.30
200.00
-
-
7.50
278.00
-
H
12.24
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTES 6, 7
SA-JER-DS011-TRJR-480019
2"
CRU
011
010005
101CH2S
2"-FLO-011010301-101CS1P-N
16"-CRU-011010005-101CH2S-H
-
-
H
50
DESALTED CRUDE
Liquid
111
4.30
200.00
-
-
7.50
278.00
-
H
12.24
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTES 6, 7
SA-JER-DS011-TRJR-480019
3/4"
CRU
011
010005
101CH2S
2"-CRU-011010005-101CH2S-H
Blind flange
-
-
H
40
DESALTED CRUDE
Liquid
111
4.30
200.00
-
-
7.50
278.00
-
H
12.24
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTES 6, 7
8"-CRU-011010006-103CS1P-H
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
111
4.30
200.00
-
-
7.50
278.00
-
H
12.24
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTES 6, 7
SA-JER-DS011-TRJR-480020
-
-
H
100
DESALTED CRUDE
Liquid
111
4.30
200.00
-
-
7.50
278.00
-
H
12.24
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTES 6, 7
011-TT-0057
-
-
H
50
DESALTED CRUDE
Liquid
111
4.30
200.00
-
-
7.50
278.00
-
H
12.24
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTES 6, 7
if NOT insulated B or Q if insulated N or Q if NOT insulated B or Q
NOTE 6
SA-JER-DS011-TRJR-480019
8"
CRU
011
010005
101CH2S
SA-JER-DS011-TRJR-480019
24"
CRU
011
010005
101CH2S
SA-JER-DS011-TRJR-480019
2"
CRU
011
010005
101CH2S 24"-CRU-011010005-101CH2S-H
SA-JER-DS011-TRJR-480020
24"
CRU
011
010005
101CH2S
SA-JER-DS011-TRJR-480019
Reducer
-
-
H
100
DESALTED CRUDE
Liquid/Gas Mixture
111
4.30
200.00
-
-
7.50
278.00
-
H
12.24
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480020
30"
CRU
011
010005
101CH2S
Reducer
011-C-0001
-
-
H
100
DESALTED CRUDE
Liquid/Gas Mixture
111
4.30
200.00
-
-
7.50
278.00
-
H
13.28
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480020
3"
CRU
011
010005
101CH2S
3"-NAP-011098002-103CH2S-P
24"-CRU-011010005-101CH2S-H
-
-
H
50
DESALTED CRUDE
Liquid/Gas Mixture
111
4.30
200.00
-
-
7.50
278.00
-
H
12.24
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480019
14"
CRU
011
010006
103CS1P
011-E-0014-A
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
755
27.40
200.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
2"
CRU
011
010006
103CS1P
12"-CRU-011010006-103CS1P-H
011-TI-0354
-
-
H
50
DESALTED CRUDE
Liquid
755
27.40
200.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
14"
CRU
011
010006
103CS1P
011-E-0014-D
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
755
27.40
200.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
2"
CRU
011
010006
103CS1P
12"-CRU-011010006-103CS1P-H
011-TI-0352
-
-
H
50
DESALTED CRUDE
Liquid
755
27.40
200.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
12"
CRU
011
010006
103CS1P
Reducer
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
755
27.40
200.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
12"
CRU
011
010006
103CS1P
Reducer
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
755
27.40
200.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
16"
CRU
011
010006
103CS1P
Reducer
Reducer
-
-
H
100
DESALTED CRUDE
Liquid
755
27.40
200.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
16"
CRU
011
010006
103CS1P
16"-CRU-011010006-103CS1P-H
Reducer
-
-
H
100
DESALTED CRUDE
Liquid
755
27.40
200.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
2"
CRU
011
010006
103CS1P
16"-CRU-011010006-103CS1P-H
011-TT-0289
-
-
H
50
DESALTED CRUDE
Liquid
755
27.40
200.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
1/2"
CRU
011
010006
103CS1P
011-FE-0006
011-FT-0006
-
-
H
40
DESALTED CRUDE
Liquid
755
27.40
200.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
16"
CRU
011
010006
103CS1P
Reducer
16"-CRU-011010006-103CS1P-H
-
-
H
100
DESALTED CRUDE
Liquid
755
27.40
200.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
8"
CRU
011
010006
103CS1P
Reducer
8"-CRU-011010005-101CH2S-H
-
-
H
65
DESALTED CRUDE
Liquid
755
27.40
200.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
1/2"
CRU
011
010006
103CS1P
011-FE-0006
011-FT-0006
-
-
H
40
DESALTED CRUDE
Liquid
755
27.40
200.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
10"
CRU
011
010006
103CS1P
Reducer
Reducer
-
-
H
65
DESALTED CRUDE
Liquid
755
27.40
200.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
16"
CRU
011
010006
103CS1P
Reducer
16"-CRU-011010005-101CH2S-H
-
-
H
100
DESALTED CRUDE
Liquid
755
27.40
200.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
3/4"
CRU
011
010007
103CS1P
16"-CRU-011010006-103CS1P-H
Insul Brk
-
-
H
40
DESALTED CRUDE
Liquid
790
27.40
200.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
3/4"
CRU
011
010007
103CS1P
Insul Brk
Reducer
-
-
P
25
DESALTED CRUDE
Liquid
790
27.40
200.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
3/4"
CRU
011
010007
103CS1P 3/4"-CRU-011010007-103CS1P-P
Plug
-
-
P
25
DESALTED CRUDE
Liquid
790
27.40
200.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
2"
CRU
011
010007
103CS1P
Reducer
2"-CLD-011010303-101CH2S-P
-
-
P
25
DESALTED CRUDE
Liquid
790
27.40
200.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480018
2"
CRU
011
010008
103CS1P
16"-CRU-011009001-103CS1P-H
Insul Brk
-
-
H
40
DESALTED CRUDE
Liquid
780
29.70
168.00
-
-
42.70
210.00
-
H
64.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480018
2"
CRU
011
010008
103CS1P
Insul Brk
2"-CLD-011010305-101CH2S-P
-
-
P
25
DESALTED CRUDE
Liquid
780
29.70
168.00
-
-
42.70
210.00
-
H
64.41
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480018
2"
CRU
011
010008
103CS1P
2"-CRU-011010008-103CS1P-P
Blind flange
-
-
P
25
DESALTED CRUDE
Liquid
780
29.70
168.00
-
-
42.70
210.00
-
H
64.41
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
2"
CRU
011
010009
103CS1P
12"-CRU-011010001-103CS1P-H
Insul Brk
-
-
H
50
DESALTED CRUDE
Liquid
770
28.50
179.30
-
-
42.70
215.00
-
H
64.73
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
2"
CRU
011
010009
103CS1P
Insul Brk
2"-CLD-011010306-101CH2S-P
-
-
P
25
DESALTED CRUDE
Liquid
770
28.50
179.30
-
-
42.70
215.00
-
H
64.73
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
2"
CRU
011
010009
103CS1P
2"-CRU-011010009-103CS1P-P
Blind flange
-
-
P
25
DESALTED CRUDE
Liquid
770
28.50
179.30
-
-
42.70
215.00
-
H
64.73
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
2"
CRU
011
010010
103CS1P
12"-CRU-011010001-103CS1P-H
Insul Brk
-
-
H
50
DESALTED CRUDE
Liquid
770
28.50
179.30
-
-
42.70
215.00
-
H
64.73
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
2"
CRU
011
010010
103CS1P
Insul Brk
2"-CLD-011010308-101CH2S-P
-
-
P
25
DESALTED CRUDE
Liquid
770
28.50
179.30
-
-
42.70
215.00
-
H
64.73
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
2"
CRU
011
010010
103CS1P
2"-CRU-011010010-103CS1P-P
Blind flange
-
-
P
25
DESALTED CRUDE
Liquid
770
28.50
179.30
-
-
42.70
215.00
-
H
64.73
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
2"
CRU
011
010011
103CS1P
12"-CRU-011010003-103CS1P-H
Insul Brk
-
-
H
50
DESALTED CRUDE
Liquid
770
28.20
187.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
2"
CRU
011
010011
103CS1P
Insul Brk
2"-CLD-011010310-101CH2S-P
-
-
P
25
DESALTED CRUDE
Liquid
770
28.20
187.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
2"
CRU
011
010011
103CS1P
2"-CRU-011010011-103CS1P-P
Blind flange
-
-
P
25
DESALTED CRUDE
Liquid
770
28.20
187.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480019
2"
CRU
011
010012
103CS1P
12"-CRU-011010002-103CS1P-H
Insul Brk
-
-
H
50
DESALTED CRUDE
Liquid
770
28.20
187.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
2"
CRU
011
010012
103CS1P
Insul Brk
2"-CLD-011010313-101CH2S-P
-
-
P
25
DESALTED CRUDE
Liquid
770
28.20
187.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS
SA-JER-DS011-TRJR-480019
2"
CRU
011
010012
103CS1P
2"-CRU-011010012-103CS1P-P
Blind flange
-
-
P
25
DESALTED CRUDE
Liquid
770
28.20
187.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS
SA-JER-DS011-TRJR-480019
4"
CRU
011
010013
103CS1P
16"-CRU-011010006-103CS1P-H
Reducer
-
-
H
50
DESALTED CRUDE
Liquid
755
27.40
200.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
B or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 10
SA-JER-DS011-TRJR-480019
3"
CRU
011
010013
103CS1P
Reducer
011-TZV-0017
-
-
H
50
DESALTED CRUDE
Liquid
755
27.40
200.00
-
-
42.50
230.00
-
H
65.41
NFS
By Code
B or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 10
Y
POTENTIAL
N
N
N
N
-
-
Reducer
NOTE 6
if insulated N or Q SA-JER-DS011-TRJR-480019
-
CRU
011
010601
106CS1P
011-E-0014-A/B/C/D/E/F
TRIM
-
-
H
-
-
-
-
27.40
200.00
-
-
43.00
230.00
-
Visual Test
0.00
NFS
By Code
SA-JER-DS011-TRJR-480020
24"
CRU
011
011001
SA-JER-DS011-TRJR-480020
2"
CRU
011
011001
106CS1P
011-ZV-0002
SA-JER-DS011-TRJR-480021
-
-
H
100
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
106CS1P
24"-CRU-011011001-106CS1P-H
011-TT-0060
-
-
H
50
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480021
24"
CRU
011
011001
SA-JER-DS011-TRJR-480021
24"
CRU
011
011001
NOTE 6
106CS1P
SA-JER-DS011-TRJR-480020
24"-CRU-011011002-106CS1P-H
-
-
H
100
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
106CS1P
24"-CRU-011011002-106CS1P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480021
20"
CRU
011
NOTE 6
011001
106CS1P
Reducer
20"-CRU-011011003-106CS1P-H
-
-
H
100
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480021
20"
CRU
NOTE 6
011
011002
106CS1P
Reducer
20"-CRU-011011002-106CS1P-H
-
-
H
100
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480021
20"
NOTE 6
CRU
011
011002
106CS1P
20"-CRU-011011002-106CS1P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480021
NOTE 6
2"
CRU
011
011002
106CS1P
20"-CRU-011011002-106CS1P-H
UC
-
-
H
50
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480021
NOTE 6
2"
CRU
011
011002
106CS1P
2"-FLO-011011301-101CS1P-N
Insul Brk
-
-
H
50
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
if NOT insulated B or Q
Page 49 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011002
106CS1P
20"-CRU-011011002-106CS1P-H
011-PI-0148
-
-
H
40
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011002
106CS1P
20"-CRU-011011002-106CS1P-H
011-PI-0360
-
-
H
40
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011002
106CS1P
2"-CRU-011011002-106CS1P-P
Blind flange
-
-
H
40
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
2"
CRU
011
011002
106CS1P
Insul Brk
20"-CRU-011011002-106CS1P-H
-
-
H
50
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
18"
CRU
011
011002
106CS1P
Reducer
011-G-0004-A
-
-
H
100
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
24"
CRU
011
011002
106CS1P
24"-CRU-011011001-106CS1P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
20"
CRU
011
011003
106CS1P
20"-CRU-011011001-106CS1P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
2"
CRU
011
011003
106CS1P
2"-FLO-011011302-101CS1P-N
Insul Brk
-
-
H
50
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
2"
CRU
011
011003
106CS1P
20"-CRU-011011003-106CS1P-H
UC
-
-
H
50
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
2"
CRU
011
011003
106CS1P
Insul Brk
20"-CRU-011011003-106CS1P-H
-
-
H
50
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011003
106CS1P
20"-CRU-011011003-106CS1P-H
011-PI-0361
-
-
H
40
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011003
106CS1P
20"-CRU-011011003-106CS1P-H
011-PI-0175
-
-
H
40
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011003
106CS1P
2"-CRU-011011003-106CS1P-P
Blind flange
-
-
H
40
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
18"
CRU
011
011003
106CS1P
Reducer
011-G-0004-B
-
-
H
100
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
12"
CRU
011
011004
106CS1P
011-G-0004-A
Reducer
-
-
H
65
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
16"
CRU
011
011004
106CS1P
Reducer
16"-CRU-011011004-106CS1P-H
-
-
H
100
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011004
106CS1P
16"-CRU-011011004-106CS1P-H
011-PI-0015
-
-
H
40
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011004
106CS1P
16"-CRU-011011004-106CS1P-H 16"-CRU-011011004-106CS1P-H
-
-
H
40
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
16"
CRU
011
011004
106CS1P
SA-JER-DS011-TRJR-480021
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
CRU
011
011004
106CS1P
16"-CRU-011011004-106CS1P-H
Blind flange
-
-
H
50
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
20"
CRU
011
011004
106CS1P
Reducer
011-E-0015-B
-
-
H
100
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
16"
CRU
011
011004
106CS1P
16"-CRU-011011004-106CS1P-H
SA-JER-DS011-TRJR-480024
-
-
H
100
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
1/2"
CRU
011
011004
106CS1P
011-FE-0008
011-FT-0008-A
-
-
H
40
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
1/2"
CRU
011
011004
106CS1P
011-FE-0008
011-FT-0008-B
-
-
H
40
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011004
106CS1P
16"-CRU-011011004-106CS1P-H
011-PT-0451
-
-
H
40
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
1/2"
CRU
011
011004
106CS1P
011-FE-0008
011-FT-0008-A
-
-
H
40
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
1/2"
CRU
011
011004
106CS1P
011-FE-0008
011-FT-0008-B
-
-
H
40
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480245
3/4"
CRU
011
011004
106CS1P
SA-JER-DS011-TRJR-480021
2"-OLW-011171311-101CS1P-N
-
-
P
25
TOPPED CRUDE
Liquid
800
0.00
27.00
-
-
0.00
60.00
-
H
0.00
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
12"
CRU
011
011005
101CS1P
12"-CRU-011011014-106CS1P-H
SA-JER-DS011-TRJR-480020
-
-
H
65
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
7.00
278.00
-
H
11.43
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480020
12"
CRU
011
011005
101CS1P
SA-JER-DS011-TRJR-480021
011-C-0001
-
-
H
65
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
7.00
278.00
-
H
11.43
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480020
6"
CRU
011
011006
106CS1P
24"-CRU-011011001-106CS1P-H
Insul Brk
-
-
H
50
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480020
6"
CRU
011
011006
106CS1P
Insul Brk
6"-CLD-011011301-101CH2S-P
-
-
P
40
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480020
3/4"
CRU
011
011006
106CS1P
6"-CRU-011011006-106CS1P-P
Blind flange
-
-
P
25
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480020
3/4"
CRU
011
011006
103CS1P
011-LG-0002-B
3/4"-CRU-011011006-106CS1P-P
-
-
P
25
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
5.30
230.00
-
H
8.16
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480020
3/4"
CRU
011
011006
106CS1P 3/4"-CRU-011011006-103CS1P-P
6"-CRU-011011006-106CS1P-P
-
-
P
25
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480020
3/4"
CRU
011
011006
103CS1P
3/4"-CRU-011011006-106CS1P-P
-
-
P
25
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
5.30
230.00
-
H
8.16
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480020
3/4"
CRU
011
011006
106CS1P 3/4"-CRU-011011006-103CS1P-P 3/4"-CRU-011011006-106CS1P-P
-
-
P
25
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
2"
CRU
011
011008
106CS1P
16"-CRU-011011004-106CS1P-H
Insul Brk
-
-
H
50
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
2"
CRU
011
011008
106CS1P
Insul Brk
2"-CLD-011011302-101CH2S-P
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011008
106CS1P
2"-CRU-011011008-106CS1P-P
3/4"-OLW-011011301-101CS1PN
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011008
106CS1P
011-G-0004-A
2"-CRU-011011008-106CS1P-P
-
-
P
25
NAPHTHA
Gas
-
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011008
106CS1P
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011008
106CS1P 3/4"-CRU-011011008-106CS1P-P
2"-CRU-011011008-106CS1P-P
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
2"
CRU
011
011008
106CS1P
18"-CRU-011011002-106CS1P-H
2"-CRU-011011008-106CS1P-P
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
2"
CRU
011
011008
106CS1P
2"-CRU-011011008-106CS1P-P
2"-CRU-011011008-106CS1P-P
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011008
106CS1P
011-G-0004-A
Reducer
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
2"
CRU
011
011008
106CS1P
Reducer
2"-CRU-011011008-106CS1P-P
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
2"
CRU
011
011009
106CS1P
16"-CRU-011011011-106CS1P-H
Insul Brk
-
-
H
50
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
2"
CRU
011
011009
106CS1P
Insul Brk
2"-CLD-011011303-101CH2S-P
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011009
106CS1P
2"-CRU-011011009-106CS1P-P
3/4"-OLW-011011302-101CS1PN
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011009
106CS1P
011-G-0004-B
2"-CRU-011011009-106CS1P-P
-
-
P
25
NAPHTHA
Gas
-
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011009
106CS1P
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011009
106CS1P 3/4"-CRU-011011009-106CS1P-P
2"-CRU-011011009-106CS1P-P
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
2"
CRU
011
011009
106CS1P
18"-CRU-011011003-106CS1P-H
2"-CRU-011011009-106CS1P-P
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
2"
CRU
011
011009
106CS1P
2"-CRU-011011009-106CS1P-P
2"-CRU-011011009-106CS1P-P
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011009
106CS1P
011-G-0004-B
Reducer
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
2"
CRU
011
011009
106CS1P
Reducer
2"-CRU-011011009-106CS1P-P
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011010
106CS1P
12"-CRU-011011014-106CS1P-H
Insul Brk
-
-
H
40
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011010
106CS1P
Insul Brk
Reducer
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011010
106CS1P 3/4"-CRU-011011010-106CS1P-P
Blind flange
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
2"
CRU
011
011010
106CS1P
Reducer
2"-CLD-011011304-101CH2S-P
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
12"
CRU
011
011011
106CS1P
011-G-0004-B
Reducer
-
-
H
65
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
16"
CRU
011
011011
106CS1P
Reducer
16"-CRU-011011011-106CS1P-H
-
-
H
100
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011011
106CS1P
16"-CRU-011011011-106CS1P-H 16"-CRU-011011011-106CS1P-H
-
-
H
40
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
3/4"
CRU
011
011011
106CS1P
16"-CRU-011011011-106CS1P-H
011-PI-0016
-
-
H
40
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480245
3/4"
CRU
011
011011
106CS1P
2"-OLW-011171312-101CS1P-N
-
-
P
25
TOPPED CRUDE
Liquid
800
0.00
27.00
-
-
0.00
60.00
-
H
0.00
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
16"
CRU
011
011011
106CS1P
16"-CRU-011011011-106CS1P-H 16"-CRU-011011004-106CS1P-H
-
-
H
100
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480020
24"
CRU
011
011012
101CS1P
011-C-0001
011-ZV-0002
-
-
H
100
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
5.30
278.00
-
H
8.65
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
12"
CRU
011
011014
106CS1P
16"-CRU-011011004-106CS1P-H
Reducer
-
-
H
65
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
8"
CRU
011
011014
106CS1P
Reducer
Reducer
-
-
H
65
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
12"
CRU
011
011014
106CS1P
Reducer
12"-CRU-011011005-101CS1P-H
-
-
H
65
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
011-C-0001
6"-OLW-011011303-101CS1P-N
-
-
H
50
TOPPED CRUDE
Liquid
800
3.90
188.00
-
-
5.30
278.00
-
H
8.65
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
3/4"-LFL-011011303-101CH2F-N
-
-
P
25
TOPPED CRUDE
Gas
-
3.90
188.00
-
-
5.30
278.00
-
H
8.65
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Plug
-
-
P
25
TOPPED CRUDE
Gas
-
3.90
188.00
-
-
5.30
278.00
-
H
8.65
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
3/4"-LFL-011011302-101CH2F-N
-
-
P
25
TOPPED CRUDE
Gas
-
3.90
188.00
-
-
5.30
278.00
-
H
8.65
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Plug
-
-
P
25
TOPPED CRUDE
Gas
-
3.90
188.00
-
-
5.30
278.00
-
H
8.65
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 bara (HALF VACUUM) @ 200ºC.
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 bara (HALF VACUUM) @ 200ºC.
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 bara (HALF VACUUM) @ 200ºC.
011-LG-0002-A
20"-CRU-011011002-106CS1P-H 3/4"-CRU-011011008-106CS1P-P
20"-CRU-011011003-106CS1P-H 3/4"-CRU-011011009-106CS1P-P
SA-JER-DS011-TRJR-480021
SA-JER-DS011-TRJR-480020
6"
CRU
011
011015
101CS1P
SA-JER-DS011-TRJR-480020
3/4"
CRU
011
011301
101CS1P
SA-JER-DS011-TRJR-480020
3/4"
CRU
011
011301
101CS1P 3/4"-CRU-011011301-101CS1P-P
SA-JER-DS011-TRJR-480020
3/4"
CRU
011
011302
101CS1P
SA-JER-DS011-TRJR-480020
3/4"
CRU
011
011302
101CS1P 3/4"-CRU-011011302-101CS1P-P
011-LG-0002-A
011-LG-0002-B
if insulated N or Q SA-JER-DS011-TRJR-480020
-
CRU
011
011601
103CS1P
011-C-0001
TRIM
-
-
H
-
-
-
-
3.90
188.00
-
-
5.30
278.00
-
Visual Test
0.00
NFS
By Code
SA-JER-DS011-TRJR-480020
2"
CRU
011
011601
103CS1P
011-C-0001
011-PI-0014
-
-
H
50
-
-
-
3.90
188.00
-
-
5.30
278.00
-
H
8.65
NFS
By Code
SA-JER-DS011-TRJR-480020
2"
CRU
011
011601
103CS1P
011-C-0001
011-PT-0012-C
-
-
H
50
-
-
-
3.90
188.00
-
-
5.30
278.00
-
H
8.65
NFS
By Code
SA-JER-DS011-TRJR-380001
if NOT insulated B or Q if insulated N or Q if NOT insulated B or Q if insulated N or Q if NOT insulated B or Q
Page 50 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7) if insulated N or Q
SA-JER-DS011-TRJR-480020
2"
CRU
011
011601
103CS1P
011-C-0001
011-PT-0452
-
-
H
50
-
-
-
3.90
188.00
-
-
5.30
278.00
-
H
8.65
NFS
By Code
SA-JER-DS011-TRJR-480020
2"
CRU
011
011601
103CS1P
011-C-0001
011-PI-0013
-
-
H
50
-
-
-
3.90
188.00
-
-
5.30
278.00
-
H
8.65
NFS
By Code
SA-JER-DS011-TRJR-480020
2"
CRU
011
011601
103CS1P
011-C-0001
011-PT-0012-A
-
-
H
50
-
-
-
3.90
188.00
-
-
5.30
278.00
-
H
8.65
NFS
By Code
SA-JER-DS011-TRJR-480020
2"
CRU
011
011601
103CS1P
011-C-0001
011-PT-0012-B
-
-
H
50
-
-
-
3.90
188.00
-
-
5.30
278.00
-
H
8.65
NFS
By Code
SA-JER-DS011-TRJR-480020
-
CRU
011
011602
101CS1P
011-C-0001
TRIM
-
-
H
-
-
-
-
3.90
188.00
-
-
5.30
278.00
-
Visual Test
0.00
NFS
By Code
SA-JER-DS011-TRJR-480024
12"
CRU
011
013001
106CS1P
SA-JER-DS011-TRJR-480024
20"
CRU
011
013002
106CS1P
SA-JER-DS011-TRJR-480024
16"
CRU
011
013002
SA-JER-DS011-TRJR-480024
2"
CRU
011
013002
SA-JER-DS011-TRJR-480025
16"
CRU
011
SA-JER-DS011-TRJR-480025
12"
CRU
SA-JER-DS011-TRJR-480025
14"
SA-JER-DS011-TRJR-480025
if NOT insulated B or Q if insulated N or Q if NOT insulated B or Q if insulated N or Q if NOT insulated B or Q if insulated N or Q if NOT insulated B or Q if insulated N or Q if NOT insulated B or Q
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 bara (HALF VACUUM) @ 200ºC.
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 bara (HALF VACUUM) @ 200ºC.
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 bara (HALF VACUUM) @ 200ºC.
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 bara (HALF VACUUM) @ 200ºC.
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 bara (HALF VACUUM) @ 200ºC.
-
-
H
65
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
011-E-0015-A
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
106CS1P
Reducer
SA-JER-DS011-TRJR-480025
-
-
H
100
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
106CS1P
16"-CRU-011013002-106CS1P-H
Blind flange
-
-
H
50
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
013002
106CS1P
SA-JER-DS011-TRJR-480024
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
011
013002
106CS1P
Reducer
Reducer
-
-
H
65
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
CRU
011
013002
106CS1P
Reducer
011-E-0016-A/B
-
-
H
65
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
16"
CRU
011
013002
106CS1P
16"-CRU-011013002-106CS1P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
12"
CRU
011
013002
106CS1P
Reducer
Reducer
-
-
H
65
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
14"
CRU
011
013002
106CS1P
Reducer
011-E-0016-B
-
-
H
65
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
CRU
011
013002
106CS1P
2"-FLO-011013309-101CS1P-N
Insul Brk
-
-
P
25
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
3/4"
CRU
011
013002
106CS1P
2"-CRU-011013002-106CS1P-P
Blind flange
-
-
P
25
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
CRU
011
013002
106CS1P
Insul Brk
16"-CRU-011013002-106CS1P-H
-
-
H
50
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
14"
CRU
011
013003
106CS1P
011-E-0016-A
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
12"
CRU
011
013003
106CS1P
Reducer
SA-JER-DS011-TRJR-480026
-
-
H
100
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
CRU
011
013003
106CS1P
12"-CRU-011013003-106CS1P-H
Blind flange
-
-
H
50
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
12"
CRU
011
013003
106CS1P
SA-JER-DS011-TRJR-480025
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
14"
CRU
011
013003
106CS1P
Reducer
011-E-0017-A
-
-
H
100
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
CRU
011
013003
106CS1P
2"-FLO-011013311-101CS1P-N
Insul Brk
-
-
P
40
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
3/4"
CRU
011
013003
106CS1P
2"-CRU-011013003-106CS1P-P
Blind flange
-
-
P
25
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
CRU
011
013003
106CS1P
Insul Brk
12"-CRU-011013003-106CS1P-H
-
-
H
50
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
14"
CRU
011
013004
106CS1P
011-E-0016-B
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
12"
CRU
011
013004
106CS1P
Reducer
SA-JER-DS011-TRJR-480026
-
-
H
100
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
12"-CRU-011013004-106CS1P-H
Blind flange
-
-
H
50
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
100
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
16"-CRU-011011004-106CS1P-H 16"-CRU-011013002-106CS1P-H
SA-JER-DS011-TRJR-480025
2"
CRU
011
013004
106CS1P
SA-JER-DS011-TRJR-480026
12"
CRU
011
013004
106CS1P
SA-JER-DS011-TRJR-480025
Reducer
-
TOPPED CRUDE
Liquid
SA-JER-DS011-TRJR-480026
14"
CRU
011
013004
106CS1P
Reducer
011-E-0017-B
-
-
H
100
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
CRU
011
013004
106CS1P
2"-FLO-011013310-101CS1P-N
Insul Brk
-
-
P
40
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
3/4"
CRU
011
013004
106CS1P
2"-CRU-011013004-106CS1P-P
Blind flange
-
-
P
25
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
CRU
011
013004
106CS1P
Insul Brk
12"-CRU-011013004-106CS1P-H
-
-
H
50
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
CRU
011
013005
106CS1P
12"-CRU-011013002-106CS1P-H
Insul Brk
-
-
H
50
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
CRU
011
013005
106CS1P
Insul Brk
2"-CLD-011013303-101CH2S-P
-
-
P
25
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
CRU
011
013005
106CS1P
2"-CRU-011013005-106CS1P-P
Blind flange
-
-
P
25
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
CRU
011
013006
106CS1P
12"-CRU-011013002-106CS1P-H
Insul Brk
-
-
H
50
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
CRU
011
013006
106CS1P
Insul Brk
2"-CLD-011013305-101CH2S-P
-
-
P
25
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
CRU
011
013006
106CS1P
2"-CRU-011013006-106CS1P-P
Blind flange
-
-
P
25
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
CRU
011
013007
106CS1P
UC
Insul Brk
-
-
P
25
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6. ALTERNATE CONDITIONS FV @290ºC.
SA-JER-DS011-TRJR-480025
3/4"
CRU
011
013007
106CS1P
2"-CRU-011013007-106CS1P-P
Blind flange
-
-
P
25
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6. ALTERNATE CONDITIONS FV @290ºC.
SA-JER-DS011-TRJR-480025
2"
CRU
011
013007
106CS1P
Insul Brk
12"-CRU-011013002-106CS1P-H
-
-
H
50
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6. ALTERNATE CONDITIONS FV @290ºC.
SA-JER-DS011-TRJR-480025
2"
CRU
011
013008
106CS1P
UC
Insul Brk
-
-
P
25
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE CONDITIONS FV @ 290ºC.
SA-JER-DS011-TRJR-480025
3/4"
CRU
011
013008
106CS1P
2"-CRU-011013008-106CS1P-P
Blind flange
-
-
P
25
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE CONDITIONS FV @ 290ºC.
SA-JER-DS011-TRJR-480025
2"
CRU
011
013008
106CS1P
Insul Brk
12"-CRU-011013002-106CS1P-H
-
-
H
50
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE CONDITIONS FV @ 290ºC.
SA-JER-DS011-TRJR-480024
2"
CRU
011
013011
106CS1P
16"-CRU-011011004-106CS1P-H
Insul Brk
-
-
H
50
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
CRU
011
013011
106CS1P
Insul Brk
2"-CLD-011013312-101CH2S-P
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
CRU
011
013011
106CS1P
2"-CRU-011013011-106CS1P-P
Blind flange
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
CRU
011
013012
106CS1P
UC
Insul Brk
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
3/4"
CRU
011
013012
106CS1P
2"-CRU-011013012-106CS1P-P
Blind flange
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
CRU
011
013012
106CS1P
Insul Brk
16"-CRU-011011004-106CS1P-H
-
-
H
50
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
CRU
011
013013
106CS1P
16"-CRU-011011004-106CS1P-H
Insul Brk
-
-
H
50
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
CRU
011
013013
106CS1P
Insul Brk
2"-CLD-011013314-101CH2S-P
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
CRU
011
013013
106CS1P
2"-CRU-011013013-106CS1P-P
Blind flange
-
-
P
25
TOPPED CRUDE
Liquid
800
34.70
188.00
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
12"
CRU
011
013014
106CS1P
12"-CRU-011013002-106CS1P-H 12"-CRU-011013014-106CS1P-H
-
-
H
65
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
12"
CRU
011
013014
106CS1P
12"-CRU-011013014-106CS1P-H 12"-CRU-011013003-106CS1P-H
-
-
H
100
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
12"
CRU
011
013015
106CS1P
12"-CRU-011013002-106CS1P-H 12"-CRU-011013015-106CS1P-H
-
-
H
65
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
12"
CRU
011
013015
106CS1P
12"-CRU-011013015-106CS1P-H 12"-CRU-011013004-106CS1P-H
-
-
H
100
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
CRU
011
013016
106CS1P
16"-CRU-011013002-106CS1P-H
Insul Brk
-
-
H
50
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
CRU
011
013016
106CS1P
Insul Brk
2"-CLD-011013315-101CH2S-P
-
-
P
25
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
CRU
011
013016
106CS1P
2"-CRU-011013016-106CS1P-P
Blind flange
-
-
P
25
TOPPED CRUDE
Liquid
791
34.00
201.40
-
-
43.00
230.00
-
H
66.18
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
CRU
011
013017
106CS1P
12"-CRU-011013003-106CS1P-H
Insul Brk
-
-
H
50
TOPPED CRUDE
Liquid
818
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
CRU
011
013017
106CS1P
Insul Brk
2"-CLD-011013316-101CH2S-P
-
-
P
40
TOPPED CRUDE
Liquid
818
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
CRU
011
013017
106CS1P
2"-CRU-011013017-106CS1P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
818
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
CRU
011
013018
106CS1P
12"-CRU-011013004-106CS1P-H
Insul Brk
-
-
H
50
TOPPED CRUDE
Liquid
818
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
CRU
011
013018
106CS1P
Insul Brk
2"-CLD-011013319-101CH2S-P
-
-
P
40
TOPPED CRUDE
Liquid
818
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
CRU
011
013018
106CS1P
2"-CRU-011013018-106CS1P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
818
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
Y
POTENTIAL
N
N
N
N
-
NOTE 6
if insulated N or Q SA-JER-DS011-TRJR-480024
-
CRU
011
013601
106CS1P
011-E-0015-A/B
SA-JER-DS011-TRJR-480026
14"
CRU
011
014001
106CS1P
SA-JER-DS011-TRJR-480026
12"
CRU
011
014001
106CS1P
SA-JER-DS011-TRJR-480026
2"
CRU
011
014001
SA-JER-DS011-TRJR-480027
12"
CRU
011
SA-JER-DS011-TRJR-480027
14"
CRU
011
SA-JER-DS011-TRJR-380001
TRIM
-
-
H
-
-
-
-
33.20
201.00
-
-
43.00
230.00
-
Visual Test
0.00
NFS
By Code
011-E-0017-A
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
770
32.50
230.80
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Reducer
SA-JER-DS011-TRJR-480027
-
-
H
100
TOPPED CRUDE
Liquid
770
32.50
230.80
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
106CS1P
12"-CRU-011014001-106CS1P-H
Blind flange
-
-
H
50
TOPPED CRUDE
Liquid
770
32.50
230.80
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
014001
106CS1P
SA-JER-DS011-TRJR-480026
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
770
32.50
230.80
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
014001
106CS1P
Reducer
011-E-0018-B
-
-
H
100
TOPPED CRUDE
Liquid
770
32.50
230.80
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
if NOT insulated C or Q
Page 51 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480026
14"
CRU
011
014002
106CS1P
011-E-0017-B
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
770
32.50
230.80
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
12"
CRU
011
014002
106CS1P
Reducer
SA-JER-DS011-TRJR-480027
-
-
H
100
TOPPED CRUDE
Liquid
770
32.50
230.80
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
CRU
011
014002
106CS1P
12"-CRU-011014002-106CS1P-H
Blind flange
-
-
H
50
TOPPED CRUDE
Liquid
770
32.50
230.80
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
12"
CRU
011
014002
106CS1P
SA-JER-DS011-TRJR-480026
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
770
32.50
230.80
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
14"
CRU
011
014002
106CS1P
Reducer
011-E-0018-D
-
-
H
100
TOPPED CRUDE
Liquid
770
32.50
230.80
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
14"
CRU
011
014003
106CS2P
011-E-0018-A/C
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
14"
CRU
011
014003
106CS2P
011-E-0018-C
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
12"
CRU
011
014003
106CS2P
Reducer
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
3/4"
CRU
011
014003
106CS2P
2"-CRU-011014003-106CS2P-P
Blind flange
-
-
H
40
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
CRU
011
014003
106CS2P
12"-CRU-011014003-106CS2P-H
UC
-
-
H
65
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
3/4"
CRU
011
014003
106CS2P
2"-CRU-011014003-106CS2P-P
Blind flange
-
-
H
40
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
CRU
011
014003
106CS2P
Insul Brk
12"-CRU-011014003-106CS2P-H
-
-
H
65
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
12"
CRU
011
014003
106CS2P
Reducer
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
CRU
011
014003
106CS2P
Insul Brk
12"-CRU-011014003-106CS2P-H
-
-
H
65
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
CRU
011
014003
106CS2P
2"-FLO-011014303-101CS1P-N
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
CRU
011
014003
106CS2P
2"-FLO-011014301-101CS1P-N
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
CRU
011
014003
106CS2P
12"-CRU-011014003-106CS2P-H
UC
-
-
H
65
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
16"
CRU
011
014003
106CS2P
SA-JER-DS011-TRJR-480027
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
16"
CRU
011
014003
106CS2P
16"-CRU-011014003-106CS2P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
12"
CRU
011
014003
106CS2P
Reducer
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
12"
CRU
011
014003
106CS2P
Reducer
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
14"
CRU
011
014003
106CS2P
Reducer
011-E-0019-C/F
-
-
H
100
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
14"
CRU
011
014003
106CS2P
Reducer
011-E-0019-F
-
-
H
100
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
16"
CRU
011
014003
106CS2P
Reducer
SA-JER-DS011-TRJR-480028
-
-
H
100
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
16"
CRU
011
014003
106CS2P
Reducer
16"-CRU-011014003-106CS2P-H
-
-
H
100
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
CRU
011
014004
106CS1P
12"-CRU-011013004-106CS1P-H
Insul Brk
-
-
H
50
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
CRU
011
014004
106CS1P
Insul Brk
2"-CLD-011014302-101CH2S-P
-
-
P
40
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
CRU
011
014004
106CS1P
2"-CRU-011014004-106CS1P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
CRU
011
014005
106CS1P
12"-CRU-011013003-106CS1P-H
Insul Brk
-
-
H
50
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
CRU
011
014005
106CS1P
Insul Brk
2"-CLD-011014301-101CH2S-P
-
-
P
40
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
CRU
011
014005
106CS1P
2"-CRU-011014005-106CS1P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
775
33.00
222.70
-
-
43.00
260.00
-
H
68.25
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
CRU
011
014006
106CS1P
12"-CRU-011014001-106CS1P-H
Insul Brk
-
-
H
50
TOPPED CRUDE
Liquid
770
32.50
230.80
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
CRU
011
014006
106CS1P
Insul Brk
2"-CLD-011014307-101CH2S-P
-
-
P
40
TOPPED CRUDE
Liquid
770
32.50
230.80
-
-
43.00
260.00
-
H
68.25
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
CRU
011
014006
106CS1P
2"-CRU-011014006-106CS1P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
770
32.50
230.80
-
-
43.00
260.00
-
H
68.25
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
CRU
011
014008
106CS1P
12"-CRU-011014002-106CS1P-H
Insul Brk
-
-
H
50
TOPPED CRUDE
Liquid
770
32.50
230.80
-
-
43.00
260.00
-
H
68.25
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
CRU
011
014008
106CS1P
Insul Brk
2"-CLD-011014309-101CH2S-P
-
-
P
40
TOPPED CRUDE
Liquid
770
32.50
230.80
-
-
43.00
260.00
-
H
68.25
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
CRU
011
014008
106CS1P
2"-CRU-011014008-106CS1P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
770
32.50
230.80
-
-
43.00
260.00
-
H
68.25
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
CRU
011
014009
106CS2P
12"-CRU-011014003-106CS2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
929
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
CRU
011
014009
106CS2P
Insul Brk
2"-CLD-011014316-101CH2S-P
-
-
P
40
TOPPED CRUDE
Liquid
929
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
CRU
011
014009
106CS2P
2"-CRU-011014009-106CS2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
929
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
CRU
011
014010
106CS2P
12"-CRU-011014003-106CS2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
929
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
CRU
011
014010
106CS2P
Insul Brk
2"-CLD-011014318-101CH2S-P
-
-
P
40
TOPPED CRUDE
Liquid
929
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
CRU
011
014010
106CS2P
2"-CRU-011014010-106CS2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
929
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
Y
POTENTIAL
N
N
N
N
-
NOTE 6
if insulated N or Q SA-JER-DS011-TRJR-480027
-
CRU
011
014601
106CS2P
NFS
By Code
SA-JER-DS011-TRJR-480028
12"
CRU
011
015001
106CS2P
-
-
H
100
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
SA-JER-DS011-TRJR-480028
14"
CRU
011
015002
106CL2P
011-E-0019-C
011-E-0019-B
-
-
H
100
TOPPED CRUDE
Liquid
752
30.50
253.80
-
-
43.00
310.00
-
H
SA-JER-DS011-TRJR-480028
2"
CRU
011
015002
106CL2P
14"-CRU-011015002-106CL2P-H
Blind flange
-
-
H
65
TOPPED CRUDE
Liquid
752
30.50
253.80
-
-
43.00
310.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
76.65 76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480028
14"
CRU
011
015003
106CL2P
011-E-0019-F
011-E-0019-E
-
-
H
100
TOPPED CRUDE
Liquid
752
30.50
253.80
-
-
43.00
310.00
-
H
NOTE 6
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480028
2"
CRU
011
015003
106CL2P
14"-CRU-011015003-106CL2P-H
Blind flange
-
-
H
65
TOPPED CRUDE
Liquid
752
30.50
253.80
-
-
43.00
310.00
-
NOTE 6
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480028
14"
CRU
011
015004
106CL2P
011-E-0019-A/D
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
NOTE 6
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480028
14"
CRU
011
015004
106CL2P
011-E-0019-D
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
NOTE 6
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480028
12"
CRU
011
015004
106CL2P
Reducer
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
SA-JER-DS011-TRJR-480028
2"
CRU
011
015004
106CL2P
12"-CRU-011015004-106CL2P-H
Blind flange
-
-
H
65
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
NOTE 6
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480028
12"
CRU
011
015004
106CL2P
Reducer
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
733
28.90
276.10
-
NOTE 6
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480028
3/4"
CRU
011
015004
106CL2P
2"-CRU-011015004-106CL2P-P
Blind flange
-
-
H
65
TOPPED CRUDE
Liquid
733
28.90
276.10
NOTE 6
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480028
2"
CRU
011
015004
106CL2P
Insul Brk
12"-CRU-011015004-106CL2P-H
-
-
H
65
TOPPED CRUDE
Liquid
733
28.90
NOTE 6
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480028
3/4"
CRU
011
015004
106CL2P
2"-CRU-011015004-106CL2P-P
Blind flange
-
-
H
65
TOPPED CRUDE
Liquid
733
NOTE 6
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480028
2"
CRU
011
015004
106CL2P
2"-FLO-011015301-101CS1P-N
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
NOTE 6
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480028
2"
CRU
011
015004
106CL2P
Insul Brk
12"-CRU-011015004-106CL2P-H
-
-
H
65
TOPPED CRUDE
NOTE 6
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480028
2"
CRU
011
015004
106CL2P
2"-FLO-011015303-101CS1P-N
Insul Brk
-
-
H
65
SA-JER-DS011-TRJR-480028
2"
CRU
011
015004
106CL2P
12"-CRU-011015004-106CL2P-H
Blind flange
-
-
H
65
NOTE 6
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480029
16"
CRU
011
015004
106CL2P
SA-JER-DS011-TRJR-480028
Reducer
-
-
H
NOTE 6
100
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480029
16"
CRU
011
015004
106CL2P
16"-CRU-011015004-106CL2P-H
Reducer
-
-
NOTE 6
H
100
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480029
12"
CRU
011
015004
106CL2P
Reducer
Reducer
-
NOTE 6
-
H
100
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480029
12"
CRU
011
015004
106CL2P
Reducer
Reducer
NOTE 6
-
-
H
100
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480029
14"
CRU
011
015004
106CL2P
Reducer
NOTE 6
011-E-0020-C/F
-
-
H
100
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480029
14"
CRU
011
015004
106CL2P
SA-JER-DS011-TRJR-480028
16"
CRU
011
015004
106CL2P
NOTE 6
Reducer
011-E-0020-F
-
-
H
100
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Reducer
SA-JER-DS011-TRJR-480029
-
-
H
100
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480028
16"
CRU
011
015004
NOTE 6
106CL2P
Reducer
16"-CRU-011015004-106CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480029
14"
CRU
011
NOTE 6
015005
106CL2P
011-E-0020-C
011-E-0020-B
-
-
H
100
TOPPED CRUDE
Liquid
728
28.20
281.90
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480029
2"
CRU
NOTE 6
011
015005
106CL2P
14"-CRU-011015005-106CL2P-H
UC
-
-
H
65
TOPPED CRUDE
Liquid
728
28.20
281.90
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480029
2"
NOTE 6
CRU
011
015005
106CL2P
14"-CRU-011015005-106CL2P-H
011-TW-0310
-
-
H
65
TOPPED CRUDE
Liquid
728
28.20
281.90
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480029
NOTE 6
14"
CRU
011
015006
106CL2P
011-E-0020-F
011-E-0020-E
-
-
H
100
TOPPED CRUDE
Liquid
728
28.20
281.90
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015006
106CL2P
14"-CRU-011015006-106CL2P-H
UC
-
-
H
65
TOPPED CRUDE
Liquid
728
28.20
281.90
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015006
106CL2P
14"-CRU-011015006-106CL2P-H
011-TW-0316
-
-
H
65
TOPPED CRUDE
Liquid
728
28.20
281.90
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
14"
CRU
011
015007
106CL2P
011-E-0020-A/D
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
14"
CRU
011
015007
106CL2P
011-E-0020-D
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015007
106CL2P
Flange
12"-CRU-011015007-106CL2P-H
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
12"
CRU
011
015007
106CL2P
Reducer
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015007
106CL2P
Insul Brk
12"-CRU-011015007-106CL2P-H
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015007
106CL2P
2"-FLO-011015308-101CS1P-N
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015007
106CL2P
Flange
12"-CRU-011015007-106CL2P-H
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015007
106CL2P
12"-CRU-011015007-106CL2P-H
Blind flange
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015007
106CL2P
2"-FLO-011015306-101CS1P-N
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
3/4"
CRU
011
015007
106CL2P
2"-CRU-011015007-106CL2P-P
Blind flange
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
3/4"
CRU
011
015007
106CL2P
2"-CRU-011015007-106CL2P-P
Blind flange
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
12"
CRU
011
015007
106CL2P
Reducer
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015007
106CL2P
Insul Brk
12"-CRU-011015007-106CL2P-H
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
011-E-0018-A/B/C/D/E/F
TRIM
16"-CRU-011014003-106CS2P-H 12"-CRU-011015017-106CL2P-H
-
-
H
-
-
-
-
29.60
245.00
-
-
43.00
280.00
-
Visual Test
0.00
if NOT insulated C or Q
Page 52 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
TO
TYPE
INSULATION (NOTE 2)
TEMP. (ºC)
TYPE
FLUID
THICKNESS (mm)
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480029
2"
CRU
011
015007
106CL2P
12"-CRU-011015007-106CL2P-H
Blind flange
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480311
16"
CRU
011
015007
106CL2P
SA-JER-DS011-TRJR-480029
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480311
8"
CRU
011
015007
106CL2P
Reducer
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480311
6"
CRU
011
015007
106CL2P
Reducer
6"-CRU-011015018-106CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480311
6"
CRU
011
015007
106CL2P
16"-CRU-011015007-106CL2P-H
SA-JER-DS011-TRJR-480033
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
16"
CRU
011
015007
106CL2P
Reducer
SA-JER-DS011-TRJR-480311
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
16"
CRU
011
015007
106CL2P
Reducer
16"-CRU-011015007-106CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480311
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
65
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
6"
CRU
011
015007
106CL2P
SA-JER-DS011-TRJR-480033
1/2"
CRU
011
015007
106CL2P
011-FT-0015-HA/HB/HC
011-FT-0015-HC
-
TOPPED CRUDE
Liquid
SA-JER-DS011-TRJR-480033
1/2"
CRU
011
015007
106CL2P
011-FT-0015-HA/HB/HC
011-FT-0015-HC
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
4"
CRU
011
015007
106CL2P
Reducer
4"-CRU-011017009-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
1/2"
CRU
011
015007
106CL2P
011-FT-0015-HA/HB/HC
011-FT-0015-HB
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
1/2"
CRU
011
015007
106CL2P
011-FT-0015-HA/HB/HC
011-FT-0015-HA
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
6"
CRU
011
015007
106CL2P
6"-CRU-011015007-106CL2P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
1/2"
CRU
011
015007
106CL2P
011-FT-0015-HA/HB/HC
011-FT-0015-HB
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
1/2"
CRU
011
015007
106CL2P
011-FT-0015-HA/HB/HC
011-FT-0015-HA
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
4"
CRU
011
015007
106CL2P
Reducer
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
6"
CRU
011
015007
106CL2P
Reducer
6"-CRU-011017009-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
10"
CRU
011
015008
106CL2P
16"-CRU-011015004-106CL2P-H 16"-CRU-011015007-106CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
CRU
011
015009
106CS2P
12"-CRU-011014003-106CS2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
CRU
011
015009
106CS2P
Insul Brk
2"-CLD-011015301-101CH2S-P
-
-
P
40
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
CRU
011
015009
106CS2P
2"-CRU-011015009-106CS2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
CRU
011
015010
106CS2P
12"-CRU-011014003-106CS2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
CRU
011
015010
106CS2P
Insul Brk
2"-CLD-011015303-101CH2S-P
-
-
P
40
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
CRU
011
015010
106CS2P
2"-CRU-011015010-106CS2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
CRU
011
015011
106CL2P
14"-CRU-011015003-106CL2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
752
30.50
253.80
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
CRU
011
015011
106CL2P
Insul Brk
2"-CLD-011015307-101CH2S-P
-
-
P
40
TOPPED CRUDE
Liquid
752
30.50
253.80
-
-
43.00
310.00
-
H
76.65
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
CRU
011
015011
106CL2P
2"-CRU-011015011-106CL2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
752
30.50
253.80
-
-
43.00
310.00
-
H
76.65
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
CRU
011
015012
106CL2P
14"-CRU-011015002-106CL2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
752
30.50
253.80
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
CRU
011
015012
106CL2P
Insul Brk
2"-CLD-011015305-101CH2S-P
-
-
P
40
TOPPED CRUDE
Liquid
752
30.50
253.80
-
-
43.00
310.00
-
H
76.65
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
CRU
011
015012
106CL2P
2"-CRU-011015012-106CL2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
752
30.50
253.80
-
-
43.00
310.00
-
H
76.65
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015013
106CL2P
12"-CRU-011015004-106CL2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015013
106CL2P
Insul Brk
2"-CLD-011015309-101CH2S-P
-
-
P
40
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015013
106CL2P
2"-CRU-011015013-106CL2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015014
106CL2P
14"-CRU-011015005-106CL2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
728
28.20
281.90
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015014
106CL2P
Insul Brk
2"-CLD-011015313-101CH2S-P
-
-
P
40
TOPPED CRUDE
Liquid
728
28.20
281.90
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015014
106CL2P
2"-CRU-011015014-106CL2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
728
28.20
281.90
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015015
106CL2P
12"-CRU-011015004-106CL2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015015
106CL2P
Insul Brk
2"-CLD-011015311-101CH2S-P
-
-
P
40
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015015
106CL2P
2"-CRU-011015015-106CL2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015016
106CL2P
14"-CRU-011015006-106CL2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
728
28.20
281.90
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015016
106CL2P
Insul Brk
2"-CLD-011015315-101CH2S-P
-
-
P
40
TOPPED CRUDE
Liquid
728
28.20
281.90
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015016
106CL2P
2"-CRU-011015016-106CL2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
728
28.20
281.90
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
12"
CRU
011
015017
106CL2P
-
-
H
100
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480311
6"
CRU
011
015018
106CL2P
6"-CRU-011015007-106CL2P-H
SA-JER-DS011-TRJR-480030
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
6"
CRU
011
015018
106CL2P
SA-JER-DS011-TRJR-480311
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
1/2"
CRU
011
015018
106CL2P
011-FE-0015-AA/AC
011-FT-0015-AB
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
1/2"
CRU
011
015018
106CL2P
011-FE-0015-AA/AC
011-FT-0015-AB
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
6"
CRU
011
015018
106CL2P
6"-CRU-011015018-106CL2P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
4"
CRU
011
015018
106CL2P
Reducer
4"-CRU-011016001-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
1/2"
CRU
011
015018
106CL2P
011-FE-0015-AA/AC
011-FT-0015-AC
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
1/2"
CRU
011
015018
106CL2P
011-FE-0015-AA/AC
011-FT-0015-AC
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
1/2"
CRU
011
015018
106CL2P
011-FE-0015-AA/AC
011-FT-0015-AA
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
1/2"
CRU
011
015018
106CL2P
011-FE-0015-AA/AC
011-FT-0015-AA
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
4"
CRU
011
015018
106CL2P
Reducer
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
6"
CRU
011
015018
106CL2P
Reducer
6"-CRU-011016001-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480311
6"
CRU
011
015019
106CL2P
16"-CRU-011015007-106CL2P-H
SA-JER-DS011-TRJR-480030
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
6"
CRU
011
015019
106CL2P
SA-JER-DS011-TRJR-480311
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
6"
CRU
011
015019
106CL2P
6"-CRU-011015019-106CL2P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
1/2"
CRU
011
015019
106CL2P
011-FE-0015-BA/BC
011-FT-0015-BB
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
4"
CRU
011
015019
106CL2P
Reducer
4"-CRU-011017003-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
1/2"
CRU
011
015019
106CL2P
011-FE-0015-BA/BC
011-FT-0015-BC
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
1/2"
CRU
011
015019
106CL2P
011-FE-0015-BA/BC
011-FT-0015-BC
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
1/2"
CRU
011
015019
106CL2P
011-FE-0015-BA/BC
011-FT-0015-BB
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
4"
CRU
011
015019
106CL2P
Reducer
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
6"
CRU
011
015019
106CL2P
Reducer
6"-CRU-011017003-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480311
6"
CRU
011
015020
106CL2P
16"-CRU-011015007-106CL2P-H
SA-JER-DS011-TRJR-480031
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
6"
CRU
011
015020
106CL2P
SA-JER-DS011-TRJR-480311
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
6"
CRU
011
015020
106CL2P
6"-CRU-011015020-106CL2P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
1/2"
CRU
011
015020
106CL2P
011-FE-0015-C
011-FT-0015-CA
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
4"
CRU
011
015020
106CL2P
Reducer
4"-CRU-011017004-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
1/2"
CRU
011
015020
106CL2P
011-FE-0015-C
011-FT-0015-CA
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
1/2"
CRU
011
015020
106CL2P
011-FE-0015-C
011-FT-0015-CB
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
1/2"
CRU
011
015020
106CL2P
011-FE-0015-C
011-FT-0015-CC
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
1/2"
CRU
011
015020
106CL2P
011-FE-0015-C
011-FT-0015-CB
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
1/2"
CRU
011
015020
106CL2P
011-FE-0015-C
011-FT-0015-CC
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
4"
CRU
011
015020
106CL2P
Reducer
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
6"
CRU
011
015020
106CL2P
Reducer
6"-CRU-011017004-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480311
6"
CRU
011
015021
106CL2P
16"-CRU-011015007-106CL2P-H
SA-JER-DS011-TRJR-480031
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
12"-CRU-011015001-106CS2P-H 16"-CRU-011015004-106CL2P-H
SA-JER-DS011-TRJR-480031
6"
CRU
011
015021
106CL2P
SA-JER-DS011-TRJR-480311
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
1/2"
CRU
011
015021
106CL2P
011-FE-0015-D
011-FT-0015-DA
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
6"
CRU
011
015021
106CL2P
6"-CRU-011015021-106CL2P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
1/2"
CRU
011
015021
106CL2P
011-FE-0015-D
011-FT-0015-DB
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
1/2"
CRU
011
015021
106CL2P
011-FE-0015-D
011-FT-0015-DC
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
1/2"
CRU
011
015021
106CL2P
011-FE-0015-D
011-FT-0015-DB
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
1/2"
CRU
011
015021
106CL2P
011-FE-0015-D
011-FT-0015-DA
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
4"
CRU
011
015021
106CL2P
Reducer
4"-CRU-011017005-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
1/2"
CRU
011
015021
106CL2P
011-FE-0015-D
011-FT-0015-DC
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
4"
CRU
011
015021
106CL2P
Reducer
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
6"
CRU
011
015021
106CL2P
Reducer
6"-CRU-011017005-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480311
6"
CRU
011
015022
106CL2P
16"-CRU-011015007-106CL2P-H
SA-JER-DS011-TRJR-480032
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 53 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480032
1/2"
CRU
011
015022
106CL2P
011-FE-0015-EA/EB/EC
011-FT-0015-EC
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
1/2"
CRU
011
015022
106CL2P
011-FE-0015-EA/EB/EC
011-FT-0015-EA
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
1/2"
CRU
011
015022
106CL2P
011-FE-0015-EA/EB/EC
011-FT-0015-EC
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
1/2"
CRU
011
015022
106CL2P
011-FE-0015-EA/EB/EC
011-FT-0015-EB
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
1/2"
CRU
011
015022
106CL2P
011-FE-0015-EA/EB/EC
011-FT-0015-EA
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
1/2"
CRU
011
015022
106CL2P
011-FE-0015-EA/EB/EC
011-FT-0015-EB
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
6"
CRU
011
015022
106CL2P
SA-JER-DS011-TRJR-480311
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
6"
CRU
011
015022
106CL2P
6"-CRU-011015022-106CL2P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
4"
CRU
011
015022
106CL2P
Reducer
4"-CRU-011017006-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
4"
CRU
011
015022
106CL2P
Reducer
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
6"
CRU
011
015022
106CL2P
Reducer
6"-CRU-011017006-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480311
6"
CRU
011
015023
106CL2P
16"-CRU-011015007-106CL2P-H
SA-JER-DS011-TRJR-480032
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
1/2"
CRU
011
015023
106CL2P
011-FE-0015-FA/FB/FC
011-FT-0015-FA
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
1/2"
CRU
011
015023
106CL2P
011-FE-0015-FA/FB/FC
011-FT-0015-FB
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
1/2"
CRU
011
015023
106CL2P
011-FE-0015-FA/FB/FC
011-FT-0015-FC
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
1/2"
CRU
011
015023
106CL2P
011-FE-0015-FA/FB/FC
011-FT-0015-FC
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
1/2"
CRU
011
015023
106CL2P
011-FE-0015-FA/FB/FC
011-FT-0015-FB
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
1/2"
CRU
011
015023
106CL2P
011-FE-0015-FA/FB/FC
011-FT-0015-FA
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
6"
CRU
011
015023
106CL2P
SA-JER-DS011-TRJR-480311
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
6"
CRU
011
015023
106CL2P
6"-CRU-011015023-106CL2P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
4"
CRU
011
015023
106CL2P
Reducer
4"-CRU-011017007-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
4"
CRU
011
015023
106CL2P
Reducer
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
6"
CRU
011
015023
106CL2P
Reducer
6"-CRU-011017007-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480311
6"
CRU
011
015024
106CL2P
16"-CRU-011015007-106CL2P-H
SA-JER-DS011-TRJR-480033
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
6"
CRU
011
015024
106CL2P
SA-JER-DS011-TRJR-480311
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
6"
CRU
011
015024
106CL2P
6"-CRU-011015024-106CL2P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
1/2"
CRU
011
015024
106CL2P
011-FT-0015-GA/GB/GC
011-FT-0015-GC
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
1/2"
CRU
011
015024
106CL2P
011-FT-0015-GA/GB/GC
011-FT-0015-GC
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
1/2"
CRU
011
015024
106CL2P
011-FT-0015-GA/GB/GC
011-FT-0015-GB
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
1/2"
CRU
011
015024
106CL2P
011-FT-0015-GA/GB/GC
011-FT-0015-GA
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
4"
CRU
011
015024
106CL2P
Reducer
4"-CRU-011017008-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
1/2"
CRU
011
015024
106CL2P
011-FT-0015-GA/GB/GC
011-FT-0015-GB
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
1/2"
CRU
011
015024
106CL2P
011-FT-0015-GA/GB/GC
011-FT-0015-GA
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
4"
CRU
011
015024
106CL2P
Reducer
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
6"
CRU
011
015024
106CL2P
Reducer
6"-CRU-011017008-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
CRU
011
015025
106CS2P
UC
Insul Brk
-
-
P
40
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480028
3/4"
CRU
011
015025
106CS2P
2"-CRU-011015025-106CS2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480028
2"
CRU
011
015025
106CS2P
Insul Brk
12"-CRU-011014003-106CS2P-H
-
-
H
65
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480028
2"
CRU
011
015026
106CS2P
UC
Insul Brk
-
-
P
40
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480028
3/4"
CRU
011
015026
106CS2P
2"-CRU-011015026-106CS2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480028
2"
CRU
011
015026
106CS2P
Insul Brk
12"-CRU-011014003-106CS2P-H
-
-
H
65
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480029
2"
CRU
011
015027
106CL2P
UC
Insul Brk
-
-
P
40
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC.
SA-JER-DS011-TRJR-480029
3/4"
CRU
011
015027
106CL2P
2"-CRU-011015027-106CL2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC.
SA-JER-DS011-TRJR-480029
2"
CRU
011
015027
106CL2P
Insul Brk
12"-CRU-011015004-106CL2P-H
-
-
H
65
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC.
SA-JER-DS011-TRJR-480029
2"
CRU
011
015028
106CL2P
UC
Insul Brk
-
-
P
40
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC.
SA-JER-DS011-TRJR-480029
3/4"
CRU
011
015028
106CL2P
2"-CRU-011015028-106CL2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC.
SA-JER-DS011-TRJR-480029
2"
CRU
011
015028
106CL2P
Insul Brk
12"-CRU-011015004-106CL2P-H
-
-
H
65
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC.
SA-JER-DS011-TRJR-480028
2"
CRU
011
015031
106CL2P
12"-CRU-011015004-106CL2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
CRU
011
015031
106CL2P
Insul Brk
2"-CLD-011015317-101CH2S-P
-
-
P
40
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
CRU
011
015031
106CL2P
2"-CRU-011015031-106CL2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
CRU
011
015032
106CS2P
12"-CRU-011015001-106CS2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
CRU
011
015032
106CS2P
Insul Brk
2"-CLD-011015318-101CH2S-P
-
-
P
40
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
CRU
011
015032
106CS2P
2"-CRU-011015032-106CS2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
760
31.00
244.10
-
-
43.00
280.00
-
H
70.40
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
CRU
011
015033
106CL2P
12"-CRU-011015004-106CL2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
CRU
011
015033
106CL2P
Insul Brk
2"-CLD-011015320-101CH2S-P
-
-
P
40
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
CRU
011
015033
106CL2P
2"-CRU-011015033-106CL2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015034
106CL2P
12"-CRU-011015007-106CL2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015034
106CL2P
Insul Brk
2"-CLD-011015323-101CH2S-P
-
-
P
50
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015034
106CL2P
2"-CRU-011015034-106CL2P-P
Blind flange
-
-
P
50
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015035
106CL2P
10"-CRU-011015008-106CL2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015035
106CL2P
Insul Brk
2"-CLD-011015324-101CH2S-P
-
-
P
40
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015035
106CL2P
2"-CRU-011015035-106CL2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
733
28.90
276.10
-
-
43.00
310.00
-
H
76.65
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015036
106CL2P
12"-CRU-011015007-106CL2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015036
106CL2P
Insul Brk
2"-CLD-011015327-101CH2S-P
-
-
P
50
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
CRU
011
015036
106CL2P
2"-CRU-011015036-106CL2P-P
Blind flange
-
-
P
50
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Y
POTENTIAL
N
N
N
N
-
NOTE 6
if insulated N or Q SA-JER-DS011-TRJR-480028
-
CRU
011
015601
106CL2P
011-E-0019-A/B/C/D/E/F
TRIM
-
-
H
-
-
-
-
27.90
276.00
-
-
43.00
310.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480029
-
CRU
011
015602
106CL2P
011-E-0020-A/B/C/D/E/F
TRIM
-
-
H
-
-
-
-
25.60
298.00
-
-
43.00
330.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480030
6"
CRU
011
016001
103CL2P
SA-JER-DS011-TRJR-480034
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
4"
CRU
011
016001
103CL2P
4"-CRU-011015018-106CL2P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
6"
CRU
011
016001
103CL2P
6"-MPS-011016302-103CS1P-H
6"-CRU-011016001-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
6"
CRU
011
016001
103CL2P
Reducer
6"-CRU-011016001-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480034
3/4"
CRU
011
016001
103CL2P
6"-CRU-011016001-103CL2P-H
011-PI-0026-A
-
-
H
65
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480034
3/4"
CRU
011
016001
103CL2P
6"-CRU-011016001-103CL2P-H
011-PT-0027-A
-
-
H
65
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480034
6"
CRU
011
016001
103CL2P
SA-JER-DS011-TRJR-480030
011-F-0001
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
3/4"
CRU
011
016002
106CL2P
6"-CRU-011015018-106CL2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
3/4"
CRU
011
016002
106CL2P
Insul Brk
Reducer
-
-
P
40
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
3/4"
CRU
011
016002
106CL2P
3/4"-CRU-011016002-106CL2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
2"
CRU
011
016002
106CL2P
Reducer
2"-CLD-011016301-101CH2S-P
-
-
P
50
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
3/4"
CRU
011
016003
106CL2P
6"-CRU-011015019-106CL2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
3/4"
CRU
011
016003
106CL2P
Insul Brk
Reducer
-
-
P
40
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
3/4"
CRU
011
016003
106CL2P
3/4"-CRU-011016003-106CL2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Reducer
2"-CLD-011016302-101CH2S-P
-
-
P
50
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
65
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
6"-CRU-011015018-106CL2P-H
if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q
SA-JER-DS011-TRJR-480030
2"
CRU
011
016003
106CL2P
SA-JER-DS011-TRJR-480031
3/4"
CRU
011
016004
106CL2P
6"-CRU-011015020-106CL2P-H
Insul Brk
-
TOPPED CRUDE
Liquid
SA-JER-DS011-TRJR-480031
3/4"
CRU
011
016004
106CL2P
Insul Brk
Reducer
-
-
P
40
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
3/4"
CRU
011
016004
106CL2P
3/4"-CRU-011016004-106CL2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 54 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
INSULATION (NOTE 2)
TYPE
FLUID
THICKNESS (mm)
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480031
2"
CRU
011
016004
106CL2P
Reducer
2"-CLD-011016303-101CH2S-P
-
-
P
50
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
3/4"
CRU
011
016005
106CL2P
6"-CRU-011015021-106CL2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
3/4"
CRU
011
016005
106CL2P
Insul Brk
Reducer
-
-
P
40
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
3/4"
CRU
011
016005
106CL2P
3/4"-CRU-011016005-106CL2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
2"
CRU
011
016005
106CL2P
Reducer
2"-CLD-011016304-101CH2S-P
-
-
P
50
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
3/4"
CRU
011
016006
106CL2P
6"-CRU-011015022-106CL2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
3/4"
CRU
011
016006
106CL2P
Insul Brk
Reducer
-
-
P
40
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
3/4"
CRU
011
016006
106CL2P
3/4"-CRU-011016006-106CL2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
2"
CRU
011
016006
106CL2P
Reducer
2"-CLD-011016305-101CH2S-P
-
-
P
50
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
3/4"
CRU
011
016007
106CL2P
6"-CRU-011015023-106CL2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
3/4"
CRU
011
016007
106CL2P
Insul Brk
Reducer
-
-
P
40
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
3/4"
CRU
011
016007
106CL2P
3/4"-CRU-011016007-106CL2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
2"
CRU
011
016007
106CL2P
Reducer
2"-CLD-011016306-101CH2S-P
-
-
P
50
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
3/4"
CRU
011
016008
106CL2P
6"-CRU-011015024-106CL2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
3/4"
CRU
011
016008
106CL2P
Insul Brk
Reducer
-
-
P
40
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
3/4"
CRU
011
016008
106CL2P
3/4"-CRU-011016008-106CL2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
2"
CRU
011
016008
106CL2P
Reducer
2"-CLD-011016307-101CH2S-P
-
-
P
50
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
3/4"
CRU
011
016009
106CL2P
6"-CRU-011015007-106CL2P-H
Insul Brk
-
-
H
65
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
3/4"
CRU
011
016009
106CL2P
Insul Brk
Reducer
-
-
P
40
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
3/4"
CRU
011
016009
106CL2P
3/4"-CRU-011016009-106CL2P-P
Blind flange
-
-
P
40
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
2"
CRU
011
016009
106CL2P
Reducer
2"-CLD-011016308-101CH2S-P
-
-
P
50
TOPPED CRUDE
Liquid
714
26.40
298.00
-
-
43.00
330.00
-
H
77.27
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480041
36"
CRU
011
017002
101CL2P
HEADER
SA-JER-DS011-TRJR-480044
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480041
14"
CRU
011
017002
101CL2P
SA-JER-DS011-TRJR-480037
36"-CRU-011017002-101CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480034
6"
CRU
011
017002
101CL2P
6"-CRU-011017002-101CL2P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480041
14"
CRU
011
017002
101CL2P
SA-JER-DS011-TRJR-480036
36"-CRU-011017002-101CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480036
14"
CRU
011
017002
101CL2P
Reducer
SA-JER-DS011-TRJR-480041
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480041
14"
CRU
011
017002
101CL2P
SA-JER-DS011-TRJR-480039
36"-CRU-011017002-101CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480036
2"
CRU
011
017002
101CL2P
14"-CRU-011017002-101CL2P-H
011-TT-0100-C
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480034
6"
CRU
011
017002
101CL2P
011-F-0001
6"-CRU-011017002-101CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480039
2"
CRU
011
017002
101CL2P
14"-CRU-011017002-101CL2P-H
011-TT-0100-F
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480039
6"
CRU
011
017002
101CL2P
6"-CRU-011017002-101CL2P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480036
6"
CRU
011
017002
101CL2P
011-F-0001
6"-CRU-011017002-101CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480034
2"
CRU
011
017002
101CL2P
14"-CRU-011017002-101CL2P-H
011-TT-0100-A
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480037
6"
CRU
011
017002
101CL2P
011-F-0001
Reducer
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480040
2"
CRU
011
017002
101CL2P
14"-CRU-011017002-101CL2P-H
011-TT-0100-G
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480037
14"
CRU
011
017002
101CL2P
Reducer
SA-JER-DS011-TRJR-480041
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480035
6"
CRU
011
017002
101CL2P
011-F-0001
Reducer
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480038
6"
CRU
011
017002
101CL2P
011-F-0001
Reducer
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480041
14"
CRU
011
017002
101CL2P
SA-JER-DS011-TRJR-480038
36"-CRU-011017002-101CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480040
2"
CRU
011
017002
101CL2P
14"-CRU-011017002-101CL2P-H
011-TT-0097-G
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480039
2"
CRU
011
017002
101CL2P
14"-CRU-011017002-101CL2P-H
011-TT-0100-F
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480038
2"
CRU
011
017002
101CL2P
14"-CRU-011017002-101CL2P-H
011-TT-0097-E
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480034
14"
CRU
011
017002
101CL2P
Reducer
SA-JER-DS011-TRJR-480041
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480041
14"
CRU
011
017002
101CL2P
SA-JER-DS011-TRJR-480034
36"-CRU-011017002-101CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480041
14"
CRU
011
017002
101CL2P
SA-JER-DS011-TRJR-480040
36"-CRU-011017002-101CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480039
6"
CRU
011
017002
101CL2P
011-F-0001
Blind flange
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480034
2"
CRU
011
017002
101CL2P
14"-CRU-011017002-101CL2P-H
011-TT-0097-A
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480035
2"
CRU
011
017002
101CL2P
14"-CRU-011017002-101CL2P-H
011-TT-0100-B
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480040
14"
CRU
011
017002
101CL2P
Reducer
SA-JER-DS011-TRJR-480041
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480036
6"
CRU
011
017002
101CL2P
6"-CRU-011017002-101CL2P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
14"-CRU-011017002-101CL2P-H
011-TT-0100-E
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
100
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480038
2"
CRU
011
017002
101CL2P
SA-JER-DS011-TRJR-480041
14"
CRU
011
017002
101CL2P
SA-JER-DS011-TRJR-480035
36"-CRU-011017002-101CL2P-H
-
TOPPED CRUDE
Liquid/Gas Mixture
SA-JER-DS011-TRJR-480036
2"
CRU
011
017002
101CL2P
14"-CRU-011017002-101CL2P-H
011-TT-0097-C
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480040
6"
CRU
011
017002
101CL2P
011-F-0001
Reducer
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480037
2"
CRU
011
017002
101CL2P
14"-CRU-011017002-101CL2P-H
011-TT-0100-D
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480039
14"
CRU
011
017002
101CL2P
Reducer
SA-JER-DS011-TRJR-480041
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480035
2"
CRU
011
017002
101CL2P
14"-CRU-011017002-101CL2P-H
011-TT-0097-B
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
36"-CRU-011017002-101CL2P-H
011-TT-0098
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
100
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6 NOTE 6
SA-JER-DS011-TRJR-480041
2"
CRU
011
017002
101CL2P
SA-JER-DS011-TRJR-480038
14"
CRU
011
017002
101CL2P
Reducer
SA-JER-DS011-TRJR-480041
-
TOPPED CRUDE
Liquid/Gas Mixture
SA-JER-DS011-TRJR-480037
2"
CRU
011
017002
101CL2P
14"-CRU-011017002-101CL2P-H
011-TT-0097-D
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480035
14"
CRU
011
017002
101CL2P
Reducer
SA-JER-DS011-TRJR-480041
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480041
6"
CRU
011
017002
101CL2P
011-F-0001
Reducer
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
By Vendor
By Vendor
Y
POTENTIAL
N
N
N
N
By Vendor
NOTES, 6,7.
SA-JER-DS011-TRJR-480044
36"
CRU
011
017002
101CL2P
SA-JER-DS011-TRJR-480041
011-C-0002
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6. NOTE 7.
SA-JER-DS011-TRJR-480041
14"
CRU
011
017002
101CL2P
Reducer
36"-CRU-011017002-101CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTES, 6,7.
SA-JER-DS011-TRJR-480041
2"
CRU
011
017002
101CL2P
14"-CRU-011017002-101CL2P-H
011-TT-0097-H
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTES, 6,7.
SA-JER-DS011-TRJR-480041
2"
CRU
011
017002
101CL2P
14"-CRU-011017002-101CL2P-H
011-TT-0100-H
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTES, 6,7.
SA-JER-DS011-TRJR-480030
6"
CRU
011
017003
103CL2P
6"-CRU-011015019-106CL2P-H
SA-JER-DS011-TRJR-480035
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
6"
CRU
011
017003
103CL2P
6"-MPS-011016304-103CS1P-H
6"-CRU-011017003-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
4"
CRU
011
017003
103CL2P
4"-CRU-011015019-106CL2P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
6"
CRU
011
017003
103CL2P
Reducer
6"-CRU-011017003-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480035
6"
CRU
011
017003
103CL2P
SA-JER-DS011-TRJR-480030
011-F-0001
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480035
3/4"
CRU
011
017003
103CL2P
6"-CRU-011017003-103CL2P-H
011-PT-0027-B
-
-
H
65
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480035
3/4"
CRU
011
017003
103CL2P
6"-CRU-011017003-103CL2P-H
011-PI-0026-B
-
-
H
65
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
6"
CRU
011
017004
103CL2P
6"-CRU-011015020-106CL2P-H
SA-JER-DS011-TRJR-480036
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
4"
CRU
011
017004
103CL2P
4"-CRU-011015020-106CL2P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
6"
CRU
011
017004
103CL2P
6"-MPS-011016306-103CS1P-H
6"-CRU-011017004-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
6"
CRU
011
017004
103CL2P
Reducer
6"-CRU-011017004-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480036
6"
CRU
011
017004
103CL2P
SA-JER-DS011-TRJR-480031
011-F-0001
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480036
3/4"
CRU
011
017004
103CL2P
6"-CRU-011017004-103CL2P-H
011-PT-0027-C
-
-
H
65
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480036
3/4"
CRU
011
017004
103CL2P
6"-CRU-011017004-103CL2P-H
011-PI-0026-C
-
-
H
65
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
6"
CRU
011
017005
103CL2P
6"-CRU-011015021-106CL2P-H
SA-JER-DS011-TRJR-480037
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
4"
CRU
011
017005
103CL2P
4"-CRU-011015021-106CL2P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
6"
CRU
011
017005
103CL2P
6"-MPS-011016308-103CS1P-H
6"-CRU-011017005-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480031
6"
CRU
011
017005
103CL2P
Reducer
6"-CRU-011017005-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480037
6"
CRU
011
017005
103CL2P
SA-JER-DS011-TRJR-480031
011-F-0001
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480037
3/4"
CRU
011
017005
103CL2P
6"-CRU-011017005-103CL2P-H
011-PI-0026-D
-
-
H
65
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480037
3/4"
CRU
011
017005
103CL2P
6"-CRU-011017005-103CL2P-H
011-PT-0027-D
-
-
H
65
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
6"
CRU
011
017006
103CL2P
6"-CRU-011015022-106CL2P-H
SA-JER-DS011-TRJR-480038
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
4"
CRU
011
017006
103CL2P
4"-CRU-011015022-106CL2P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
6"
CRU
011
017006
103CL2P
Reducer
6"-CRU-011017006-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
6"
CRU
011
017006
103CL2P
6"-MPS-011016310-103CS1P-H
6"-CRU-011017006-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 55 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
TO
TYPE
INSULATION (NOTE 2)
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480038
6"
CRU
011
017006
103CL2P
SA-JER-DS011-TRJR-480032
011-F-0001
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480038
3/4"
CRU
011
017006
103CL2P
6"-CRU-011017006-103CL2P-H
011-PT-0027-E
-
-
H
65
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480038
3/4"
CRU
011
017006
103CL2P
6"-CRU-011017006-103CL2P-H
011-PI-0026-E
-
-
H
65
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
6"
CRU
011
017007
103CL2P
6"-CRU-011015023-106CL2P-H
SA-JER-DS011-TRJR-480039
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
4"
CRU
011
017007
103CL2P
4"-CRU-011015023-106CL2P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
6"
CRU
011
017007
103CL2P
Reducer
6"-CRU-011017007-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
6"
CRU
011
017007
103CL2P
6"-MPS-011016312-103CS1P-H
6"-CRU-011017007-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480032
011-F-0001
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
65
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480039
6"
CRU
011
017007
103CL2P
SA-JER-DS011-TRJR-480039
3/4"
CRU
011
017007
103CL2P
6"-CRU-011017007-103CL2P-H
011-PI-0026-F
-
TOPPED CRUDE
Liquid
SA-JER-DS011-TRJR-480039
3/4"
CRU
011
017007
103CL2P
6"-CRU-011017007-103CL2P-H
011-PI-0027-F
-
-
H
65
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
6"
CRU
011
017008
103CL2P
6"-CRU-011015024-106CL2P-H
SA-JER-DS011-TRJR-480040
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
6"
CRU
011
017008
103CL2P
6"-MPS-011016301-103CS1P-H
6"-CRU-011017008-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
6"
CRU
011
017008
103CL2P
Reducer
6"-CRU-011017008-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
4"
CRU
011
017008
103CL2P
4"-CRU-011015024-106CL2P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
011-F-0001
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
65
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480040
6"
CRU
011
017008
103CL2P
SA-JER-DS011-TRJR-480040
3/4"
CRU
011
017008
103CL2P
6"-CRU-011017008-103CL2P-H
011-PT-0027-G
-
TOPPED CRUDE
Liquid
SA-JER-DS011-TRJR-480040
3/4"
CRU
011
017008
103CL2P
6"-CRU-011017008-103CL2P-H
011-PI-0026-G
-
-
H
65
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
6"
CRU
011
017009
103CL2P
6"-CRU-011015007-106CL2P-H
SA-JER-DS011-TRJR-480041
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
6"
CRU
011
017009
103CL2P
6"-MPS-011016314-103CS1P-H
6"-CRU-011017009-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
6"
CRU
011
017009
103CL2P
Reducer
6"-CRU-011017009-103CL2P-H
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480033
4"
CRU
011
017009
103CL2P
4"-CRU-011015007-106CL2P-H
Reducer
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480041
6"
CRU
011
017009
103CL2P
SA-JER-DS011-TRJR-480033
011-F-0001
-
-
H
100
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480041
3/4"
CRU
011
017009
103CL2P
6"-CRU-011017009-103CL2P-H
011-PI-0026-H
-
-
H
65
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480041
3/4"
CRU
011
017009
103CL2P
6"-CRU-011017009-103CL2P-H
011-PT-0027-H
-
-
H
65
TOPPED CRUDE
Liquid
714
16.20
298.00
-
-
20.50
395.00
-
H
45.08
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480034
2"
CRU
011
017010
101CL2P
14"-CRU-011017002-101CL2P-H
Insul Brk
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480034
2"
CRU
011
017010
101CL2P
Insul Brk
2"-CLD-011017301-101CH2S-P
-
-
P
65
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480034
2"
CRU
011
017010
101CL2P
2"-CRU-011017010-101CL2P-P
Blind flange
-
-
P
65
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480035
2"
CRU
011
017011
101CL2P
14"-CRU-011017002-101CL2P-H
Insul Brk
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480035
2"
CRU
011
017011
101CL2P
Insul Brk
2"-CLD-011017302-101CH2S-P
-
-
P
65
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480035
2"
CRU
011
017011
101CL2P
2"-CRU-011017011-101CL2P-P
Blind flange
-
-
P
65
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480036
2"
CRU
011
017012
101CL2P
14"-CRU-011017002-101CL2P-H
Insul Brk
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480036
2"
CRU
011
017012
101CL2P
Insul Brk
2"-CLD-011017303-101CH2S-P
-
-
P
65
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480036
2"
CRU
011
017012
101CL2P
2"-CRU-011017012-101CL2P-P
Blind flange
-
-
P
65
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480037
2"
CRU
011
017013
101CL2P
14"-CRU-011017002-101CL2P-H
Insul Brk
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480037
2"
CRU
011
017013
101CL2P
Insul Brk
2"-CLD-011017304-101CH2S-P
-
-
P
65
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480037
2"
CRU
011
017013
101CL2P
2"-CRU-011017013-101CL2P-P
Blind flange
-
-
P
65
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480038
2"
CRU
011
017014
101CL2P
14"-CRU-011017002-101CL2P-H
Insul Brk
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480038
2"
CRU
011
017014
101CL2P
Insul Brk
2"-CLD-011017305-101CH2S-P
-
-
P
65
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480038
2"
CRU
011
017014
101CL2P
2"-CRU-011017014-101CL2P-P
Blind flange
-
-
P
65
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480039
2"
CRU
011
017015
101CL2P
14"-CRU-011017002-101CL2P-H
Insul Brk
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480039
2"
CRU
011
017015
101CL2P
Insul Brk
2"-CLD-011017306-101CH2S-P
-
-
P
65
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480039
2"
CRU
011
017015
101CL2P
2"-CRU-011017015-101CL2P-P
Blind flange
-
-
P
65
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480040
2"
CRU
011
017016
101CL2P
14"-CRU-011017002-101CL2P-H
Insul Brk
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480040
2"
CRU
011
017016
101CL2P
Insul Brk
2"-CLD-011017307-101CH2S-P
-
-
P
65
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480040
2"
CRU
011
017016
101CL2P
2"-CRU-011017016-101CL2P-P
Blind flange
-
-
P
65
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480041
2"
CRU
011
017017
101CL2P
Insul Brk
2"-CLD-011017308-101CH2S-P
-
-
P
65
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480041
2"
CRU
011
017017
101CL2P
2"-CRU-011017017-101CL2P-P
Blind flange
-
-
P
65
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480041
2"
CRU
011
017017
101CL2P
14"-CRU-011017002-101CL2P-H
Insul Brk
-
-
H
75
TOPPED CRUDE
Liquid/Gas Mixture
29
2.00
366.50
-
-
3.50
395.00
-
H
7.70
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480034
6"
CRU
011
017401
103CL2P
011-F-0001
011-F-0001
-
-
H
100
TOPPED CRUDE
Liquid
695
10.50
318.00
-
-
20.50
410.00
-
H
47.15
Y - ES
N or Q
Y
POTENTIAL
N
N
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480035
6"
CRU
011
017402
103CL2P
011-F-0001
011-F-0001
-
-
H
100
TOPPED CRUDE
Liquid
695
10.50
318.00
-
-
20.50
410.00
-
H
47.15
- ES Y
N or Q
Y
POTENTIAL
N
N
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480036
6"
CRU
011
017403
103CL2P
011-F-0001
011-F-0001
-
-
H
100
TOPPED CRUDE
Liquid
695
10.50
318.00
-
-
20.50
410.00
-
H
47.15
Y - ES
N or Q
Y
POTENTIAL
N
N
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480037
6"
CRU
011
017404
103CL2P
011-F-0001
011-F-0001
-
-
H
100
TOPPED CRUDE
Liquid
695
10.50
318.00
-
-
20.50
410.00
-
H
47.15
Y - ES
N or Q
Y
POTENTIAL
N
N
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480038
6"
CRU
011
017405
103CL2P
011-F-0001
011-F-0001
-
-
H
100
TOPPED CRUDE
Liquid
695
10.50
318.00
-
-
20.50
410.00
-
H
47.15
Y - ES
N or Q
Y
POTENTIAL
N
N
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480039
6"
CRU
011
017406
103CL2P
011-F-0001
011-F-0001
-
-
H
100
TOPPED CRUDE
Liquid
695
10.50
318.00
-
-
20.50
410.00
-
H
47.15
Y - ES
N or Q
Y
POTENTIAL
N
N
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480040
6"
CRU
011
017407
103CL2P
011-F-0001
011-F-0001
-
-
H
100
TOPPED CRUDE
Liquid
695
10.50
318.00
-
-
20.50
410.00
-
H
47.15
Y - ES
N or Q
Y
POTENTIAL
N
N
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480041
6"
CRU
011
017408
103CL2P
011-F-0001
011-F-0001
-
-
H
100
TOPPED CRUDE
Liquid
695
10.50
318.00
-
-
20.50
410.00
-
H
47.15
Y - ES
N or Q
Y
POTENTIAL
N
N
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480044
8"
CRU
011
018001
101CL4P
011-C-0002
011-C-0002
-
-
H
100
TOPPED CRUDE
Liquid
682
1.50
350.00
-
-
4.10
395.00
-
H
9.02
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
1/2"
CRU
011
018001
101CL4P
011-FE-0117
011-FT-0117
-
-
H
65
TOPPED CRUDE
Liquid
682
1.50
350.00
-
-
4.10
395.00
-
-
-
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
2"
CRU
011
018001
101CL4P
Insul Brk
8"-CRU-011018001-101CL4P-H
-
-
H
75
TOPPED CRUDE
Liquid
682
1.50
350.00
-
-
4.10
395.00
-
H
9.02
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
1"
CRU
011
018001
101CL4P
2"-CRU-011018001-101CL4P-P
Blind flange
-
-
H
65
TOPPED CRUDE
Liquid
682
1.50
350.00
-
-
4.10
395.00
-
H
9.02
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
2"
CRU
011
018001
101CL4P
2"-FLO-011018301-101CS1P-N
Insul Brk
-
-
H
75
TOPPED CRUDE
Liquid
682
1.50
350.00
-
-
4.10
395.00
-
H
9.02
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
1/2"
CRU
011
018001
101CL4P
011-FE-0117
011-FT-0117
-
-
H
65
TOPPED CRUDE
Liquid
682
1.50
350.00
-
-
4.10
395.00
-
-
-
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
3/4"
CRU
011
018003
101CL4P
011-LG-0019
Reducer
S
33.7
H
65
TOPPED CRUDE
Gas
-
1.50
350.00
-
-
4.10
395.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
1"
CRU
011
018003
101CL4P
Reducer
1"-LFL-011018310-101CH2F-N
S
33.7
H
65
TOPPED CRUDE
Gas
-
1.50
350.00
-
-
4.10
395.00
-
H
9.02
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
1"
CRU
011
018003
101CL4P
1"-CRU-011018003-101CL4P-S
Blind flange
S
33.7
H
65
TOPPED CRUDE
Gas
-
1.50
350.00
-
-
4.10
395.00
-
H
9.02
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
2"
CRU
011
018004
101CL4P
8"-CRU-011018001-101CL4P-H
Insul Brk
-
-
H
75
TOPPED CRUDE
Liquid
682
1.50
350.00
-
-
4.10
395.00
-
H
9.02
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
2"
CRU
011
018004
101CL4P
Insul Brk
2"-CLD-011018307-101CH2S-P
-
-
P
65
TOPPED CRUDE
Liquid
682
1.50
350.00
-
-
4.10
395.00
-
H
9.02
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
1"
CRU
011
018004
101CL4P
20A
1"-OLW-011018302-101CS1P-N
-
-
P
50
TOPPED CRUDE
Liquid
682
1.50
350.00
-
-
4.10
395.00
-
H
9.02
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
1"
CRU
011
018004
101CL4P
2"-CRU-011018004-101CL4P-P
20A
-
-
P
50
TOPPED CRUDE
Liquid
682
1.50
350.00
-
-
4.10
395.00
-
H
9.02
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
if insulated N or Q Y
POTENTIAL
N
N
N
N
-
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITION : 0.5 BARA (HALF VACUUM) @ 200°C
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITION : 0.5 BARA (HALF VACUUM) @ 200°C
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
H
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
178.00
-
H
24.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
16.00
178.00
-
H
24.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
16.00
178.00
-
H
24.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
-
CRU
011
018601
103CL4P
011-C-0002
TRIM
-
-
H
-
-
-
-
1.50
350.00
-
-
4.10
395.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480044
2"
CRU
011
018601
103CL4P
011-C-0002
011-PI-0032
-
-
H
75
-
-
-
1.50
350.00
-
-
4.10
395.00
-
H
9.02
NFS
YES
SA-JER-DS011-TRJR-480044
2"
CRU
011
018601
103CL4P
011-PT-0030
011-C-0002
-
-
H
75
-
-
-
1.50
350.00
-
-
4.10
395.00
-
H
9.02
NFS
YES
SA-JER-DS011-TRJR-480133
18"
CRU
011
098001
103CS1P
IP-1314-L
SA-JER-DS011-TRJR-480001
-
-
N
-
FRESH CRUDE
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
NFS
By Code
SA-JER-DS011-TRJR-480001
18"
CRU
011
098001
103CS1P
SA-JER-DS011-TRJR-480133
SA-JER-DS011-TRJR-480002
-
-
N
-
FRESH CRUDE
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
NFS
By Code
SA-JER-DS011-TRJR-480002
18"
CRU
011
098001
103CS1P
SA-JER-DS011-TRJR-480001
18"-CRU-011098001-103CS1P-N
-
-
N
-
FRESH CRUDE
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
NFS
SA-JER-DS011-TRJR-480002
18"
CRU
011
098001
103CS1P
18"-CRU-011098001-103CS1P-N 18"-CRU-011001004-106CS1P-N
-
-
N
-
FRESH CRUDE
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
SA-JER-DS011-TRJR-480133
3/4"
CRU
011
098003
103CS1P
18"-CRU-011098001-103CS1P-N
Reducer
-
-
N
-
FRESH CRUDE
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
SA-JER-DS011-TRJR-480133
2"
CRU
011
098003
103CS1P
Reducer
2"-CLD-011098314-101CH2S-P
-
-
N
-
FRESH CRUDE
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
SA-JER-DS011-TRJR-480133
3/4"
CRU
011
098003
103CS1P
-
-
N
-
FRESH CRUDE
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
SA-JER-DS011-TRJR-480133
2"
CRU
011
098004
103CS1P
UC
18"-CRU-011098001-103CS1P-N
-
-
N
-
FRESH CRUDE
Liquid
874
2.00
40.00
-
-
16.50
80.00
SA-JER-DS011-TRJR-480274
1/2"
CRU
011
200001
103CS1P
SAMPLE COOLER
Reducer
-
-
N
-
FRESH CRUDE
Liquid
983
13.50
60.00
-
-
16.00
SA-JER-DS011-TRJR-480274
4"
CRU
011
200001
103CS1P
Reducer
Reducer
-
-
N
-
FRESH CRUDE
Liquid
983
13.50
60.00
-
-
SA-JER-DS011-TRJR-480274
1/2"
CRU
011
200001
103CS1P
Reducer
SO
-
-
N
-
FRESH CRUDE
Liquid
983
13.50
60.00
-
-
SA-JER-DS011-TRJR-380001
18"-CRU-011098001-103CS1P-N 3/4"-CRU-011098003-103CS1P-N
NOTE 6
STEAM OUT CONDITION : 0.5 BARA (HALF VACUUM) @ 200°C
if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q
Page 56 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9) CRU
UNIT
NUMBER
LINE CLASS
FROM
TO
011
200002
103CS1P
TYPE -
TEMP. (ºC) -
INSULATION (NOTE 2)
TYPE N
FLUID
THICKNESS (mm) -
PHASE
(NOTE 3)
(NOTE 4) 983
OPERATING CONDITIONS PRESS. (BARG) 12.00
TEMP. (ºC) 60.00
DESIGN CONDITIONS
ALTERNATE CONDITIONS PRESS. (BARG) -
TEMP. (ºC) -
PRESS. (BARG) 16.00
STRESS TEMP
TEMP. (ºC) 178.00
(ºC) -
TEST CONDITIONS
MEDIUM (NOTE 5) H
PRESS. (BARG) 24.00
FLUID CATEGORY (ASME B.31.3)
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6) NFS
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SAMPLE COOLER
Reducer
Y
POTENTIAL
N
N
N
N
-
NOTE 6
4"
CRU
011
200002
103CS1P
Reducer
Reducer
-
-
N
-
DESALTED CRUDE
Liquid
983
12.00
60.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
1/2"
CRU
011
200002
103CS1P
Reducer
SO
-
-
N
-
DESALTED CRUDE
Liquid
983
12.00
60.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
1/2"
CRU
011
200003
103CS1P
SAMPLE COOLER
Reducer
-
-
N
-
FRESH CRUDE
Liquid
801
13.50
60.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
4"
CRU
011
200003
103CS1P
Reducer
Reducer
-
-
N
-
FRESH CRUDE
Liquid
801
13.50
60.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
1/2"
CRU
011
200003
103CS1P
Reducer
SO
-
-
N
-
FRESH CRUDE
Liquid
801
13.50
60.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
1/2"
CRU
011
200004
103CS1P
SAMPLE COOLER
Reducer
-
-
N
-
FRESH CRUDE
Liquid
801
12.00
60.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Reducer
Reducer
-
-
N
-
FRESH CRUDE
Liquid
801
12.00
60.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
-
N
-
801
12.00
60.00
-
-
16.00
178.00
-
H
24.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
DESALTED CRUDE
Liquid
DENSITY (kg/m3)
SA-JER-DS011-TRJR-380001
SA-JER-DS011-TRJR-480274
SA-JER-DS011-TRJR-480274
1/2"
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
DOC. No.
By Code
A or Q
SA-JER-DS011-TRJR-480274
4"
CRU
011
200004
103CS1P
SA-JER-DS011-TRJR-480274
1/2"
CRU
011
200004
103CS1P
Reducer
SO
-
FRESH CRUDE
Liquid
SA-JER-DS011-TRJR-480082
28"
CWA
011
031001
101CS1P
HEADER
SA-JER-DS011-TRJR-480083
-
-
N
-
SOFT CW
Liquid
990
4.50
40.50
-
-
11.00
-1.00
80.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC.
SA-JER-DS011-TRJR-480083
28"
CWA
011
031001
101CS1P
SA-JER-DS011-TRJR-480082
SA-JER-DS011-TRJR-480085
-
-
N
-
SOFT CW
Liquid
990
4.50
40.50
-
-
11.00
-1.00
80.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC.
SA-JER-DS011-TRJR-480085
28"
CWA
011
031001
101CS1P
SA-JER-DS011-TRJR-480083
HEADER
-
-
N
-
SOFT CW
Liquid
990
4.50
40.50
-
-
11.00
-1.00
80.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX TEMPERATURE FOR THERMAL EXPANSION : 80°C
SA-JER-DS011-TRJR-480082
16"
CWA
011
031002
101CS1P
011-E-0025-A/B
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.50
40.50
-
-
11.00
-1.00
80.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC.
SA-JER-DS011-TRJR-480082
14"
CWA
011
031002
101CS1P
Reducer
28"-CWA-011031001-101CS1P-N
-
-
N
-
SOFT CW
Liquid
990
4.50
40.50
-
-
11.00
-1.00
80.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC.
SA-JER-DS011-TRJR-480082
16"
CWA
011
031003
101CS1P
011-E-0025-B
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.50
40.50
-
-
11.00
-1.00
80.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC.
SA-JER-DS011-TRJR-480082
14"
CWA
011
031003
101CS1P
Reducer
28"-CWA-011031001-101CS1P-N
-
-
N
-
SOFT CW
Liquid
990
4.50
40.50
-
-
11.00
-1.00
80.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC.
SA-JER-DS011-TRJR-480083
16"
CWA
011
031004
101CS1P
011-E-0025-C
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.50
40.50
-
-
11.00
-1.00
80.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC.
SA-JER-DS011-TRJR-480083
14"
CWA
011
031004
101CS1P
Reducer
28"-CWA-011031001-101CS1P-N
-
-
N
-
SOFT CW
Liquid
990
4.50
40.50
-
-
11.00
-1.00
80.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC.
SA-JER-DS011-TRJR-480083
16"
CWA
011
031005
101CS1P
011-E-0025-D
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.50
40.50
-
-
11.00
-1.00
80.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC.
SA-JER-DS011-TRJR-480083
14"
CWA
011
031005
101CS1P
Reducer
28"-CWA-011031001-101CS1P-N
-
-
N
-
SOFT CW
Liquid
990
4.50
40.50
-
-
11.00
-1.00
80.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC.
SA-JER-DS011-TRJR-480085
24"
CWA
011
032001
101CS1P 28"-CWA-011031001-101CS1P-N
011-E-0026
-
-
N
-
SOFT CW
Liquid
990
4.50
40.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480085
12"
CWA
011
032002
101CS1P 28"-CWA-011031001-101CS1P-N
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.50
40.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480085
10"
CWA
011
032002
101CS1P
011-E-0027
-
-
N
-
SOFT CW
Liquid
990
4.50
40.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480085
12"
CWA
011
032003
101CS1P 28"-CWA-011031001-101CS1P-N
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.50
40.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480085
10"
CWA
011
032003
101CS1P
011-E-0028
-
-
N
-
SOFT CW
Liquid
990
4.50
40.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480082
2"
CWA
011
032004
101CS1P 28"-CWA-011031001-101CS1P-N
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.50
40.50
-
-
11.00
-1.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-1.00
Reducer
Reducer
80.00
80.00
80.00
80.00
NOTE 6
MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. NOTE 10
SA-JER-DS011-TRJR-480082
1"
CWA
011
032004
101CS1P
Reducer
011-TZV-0003
-
-
N
-
SOFT CW
Liquid
990
4.50
40.50
-
-
11.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480023
1/2"
CWR
011
012301
101CS1P
Flange
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480023
1"
CWR
011
012301
101CS1P
Reducer
SA-JER-DS011-TRJR-480238
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
1"
CWR
011
012301
101CS1P
SA-JER-DS011-TRJR-480023
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWR
011
012301
101CS1P
Reducer
2"-CWR-011171316-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480049
2"
CWR
011
020001
101CS1P
011-TZV-0001
AT GRADE
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
100.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 71.3ºC. NOTE 10
SA-JER-DS011-TRJR-480049
16"
CWR
011
020301
101CS1P
011-E-0021
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.00
42.00
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 71.3ºC.
SA-JER-DS011-TRJR-480049
12"
CWR
011
020301
101CS1P
Reducer
12"-CWR-011020301-101CS1P-N
-
-
N
-
SOFT CW
Liquid
990
4.00
42.00
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 71.3ºC.
SA-JER-DS011-TRJR-480049
12"-CWR-011072308-301FE0WN
-
-
N
-
SOFT CW
Liquid
990
4.00
42.00
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480207
-
-
N
-
SOFT CW
Liquid
990
4.00
42.00
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
12"
CWR
011
020301
101CS1P
SA-JER-DS011-TRJR-480049
12"
CWR
011
020301
101CS1P 12"-CWR-011020301-101CS1P-N
-
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.00
42.00
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 71.3ºC. NOTE 10
Reducer
011-TZV-0001
-
-
N
-
SOFT CW
Liquid
990
4.00
42.00
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 71.3ºC. NOTE 10
101CS1P
011-TZV-0002
AT GRADE
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
108.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
101CS1P
011-TZV-0011
AT GRADE
-
-
N
-
AIR
Gas
809.6
0.00
27.00
-
-
0.00
108.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480049
2"
CWR
011
020302
101CS1P 12"-CWR-011020301-101CS1P-N
SA-JER-DS011-TRJR-480049
1"
CWR
011
020302
101CS1P
SA-JER-DS011-TRJR-480058
2"
CWR
011
025001
SA-JER-DS011-TRJR-480060
2"
CWR
011
025002
MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. NOTE 10
SA-JER-DS011-TRJR-480062
2"
CWR
011
025003
101CS1P
011-TZV-0012
AT GRADE
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
108.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480058
12"
CWR
011
025301
101CS1P
011-E-0023
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.00
43.00
-
-
14.10
80.00
-
H
21.15
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480058
10"
CWR
011
025301
101CS1P
Reducer
10"-CWR-011072307-301F0W-N
-
-
N
-
SOFT CW
Liquid
990
4.00
43.00
-
-
14.10
80.00
-
H
21.15
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480060
6"
CWR
011
025302
101CS1P
011-E-0034
6"-CWR-011072304-301FE0W-N
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
15.40
80.00
-
H
23.10
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480062
6"
CWR
011
025303
101CS1P
011-E-0035
6"-CWR-011072305-301FE0W-N
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
15.40
80.00
-
H
23.10
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480058
2"
CWR
011
025304
101CS1P 10"-CWR-011025301-101CS1P-N
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.00
43.00
-
-
14.10
80.00
-
H
21.15
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480058
1"
CWR
011
025304
101CS1P
Reducer
011-TZV-0002
-
-
N
-
SOFT CW
Liquid
990
4.00
43.00
-
-
14.10
80.00
-
H
21.15
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480060
2"
CWR
011
025305
101CS1P
6"-CWR-011025302-101CS1P-N
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
15.40
80.00
-
H
23.10
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480060
1"
CWR
011
025305
101CS1P
Reducer
011-TZV-0011
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
15.40
80.00
-
H
23.10
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480062
2"
CWR
011
025306
101CS1P
6"-CWR-011025303-101CS1P-N
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
15.40
80.00
-
H
23.10
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480062
1"
CWR
011
025306
101CS1P
Reducer
011-TZV-0012
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
15.40
80.00
-
H
23.10
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480082
2"
CWR
011
032001
101CS1P
011-TZV-0003
2"-CWS-011031006-101CS1P-N
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
108.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480085
20"
CWR
011
032002
101CS1P 28"-CWA-011031001-101CS1P-N 28"-CWR-011032301-101CS1P-N
-
-
N
-
SOFT CW
Liquid
990
4.50
40.50
-
-
11.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480085
28"
CWR
011
032301
101CS1P
HEADER
SA-JER-DS011-TRJR-480207
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
28"
CWR
011
032301
101CS1P
SA-JER-DS011-TRJR-480085
28"-CWR-011072309-301FE0WN
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480085
24"
CWR
011
032302
101CS1P
011-E-0026
28"-CWR-011032301-101CS1P-N
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480085
10"
CWR
011
032303
101CS1P
011-E-0027
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480085
12"
CWR
011
032303
101CS1P
Reducer
28"-CWR-011032301-101CS1P-N
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480085
10"
CWR
011
032304
101CS1P
011-E-0028
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480085
12"
CWR
011
032304
101CS1P
Reducer
28"-CWR-011032301-101CS1P-N
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480262
4"
CWR
011
035301
101CS1P
4"-CWR-011035305-101SD0P-N
Reducer
-
-
N
-
SOFT CW
Liquid
990
3.00
45.00
-
-
9.00
-1.00
80.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480262
3"
CWR
011
035301
101CS1P
Reducer
SA-JER-DS011-TRJR-480240
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
-1.00
80.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480240
3"
CWR
011
035301
101CS1P
SA-JER-DS011-TRJR-480262
3"-CWR-011080302-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
-1.00
80.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480092
4"
CWR
011
035302
101CS1P
011-E-0036
SA-JER-DS011-TRJR-480207
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480207
4"
CWR
011
035302
101CS1P
SA-JER-DS011-TRJR-480092
4"-CWR-011072312-301FE0W-N
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480092
2"
CWR
011
035303
101CS1P
4"-CWR-011035302-101CS1P-N
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480092
1"
CWR
011
035303
101CS1P
Reducer
011-TZV-0007
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480092
2"
CWR
011
035304
101CS1P
011-TZV-0007
AT GRADE
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
108.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480262
2"
CWR
011
035305
101SD0P
011-E-0043
Reducer
-
-
N
-
SOFT CW
Liquid
990
3.50
45.00
-
-
11.00
80.00
-
H
16.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. NOTE 10 -
SA-JER-DS011-TRJR-480262
4"
CWR
011
035305
101SD0P
Reducer
4"-CWR-011035301-101CS1P-N
-
-
N
-
SOFT CW
Liquid
990
3.50
45.00
-
-
11.00
80.00
-
H
16.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480091
1"
CWR
011
035306
101CS1P
011-K-0001
Reducer
-
-
N
-
SOFT CW
Liquid
990
3.50
45.00
-
-
11.00
80.00
-
H
16.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480091
2"
CWR
011
035306
101CS1P
Reducer
SA-JER-DS011-TRJR-480262
-
-
N
-
SOFT CW
Liquid
990
3.50
45.00
-
-
11.00
80.00
-
H
16.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
2"
CWR
011
035306
101CS1P
SA-JER-DS011-TRJR-480091
4"-CWR-011035305-101SD0P-N
-
-
N
-
SOFT CW
Liquid
990
3.50
45.00
-
-
11.00
80.00
-
H
16.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
2"
CWR
011
035307
101CS1P
011-TZV-0088
AT GRADE
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
108.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480262
2"
CWR
011
035308
101CS1P
3"-CWR-011035301-101CS1P-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
-1.00
80.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480262
1"
CWR
011
035308
101CS1P
Reducer
011-TZV-0088
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
-1.00
80.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480098
4"
CWR
011
037301
101CS1P
011-E-0029
4"-CWR-011072306-301FE0W-N
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
16.20
80.00
-
H
24.30
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 60ºC.
SA-JER-DS011-TRJR-480098
2"
CWR
011
037301
101CS1P
4"-CWR-011037301-101CS1P-N
2"-CWR-011037302-101CS1P-N
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
16.20
80.00
-
H
24.30
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480098
2"
CWR
011
037302
101CS1P
2"-CWR-011037301-101CS1P-N
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
16.20
80.00
-
H
24.30
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480098
1"
CWR
011
037302
101CS1P
Reducer
011-TZV-0004
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
16.20
80.00
-
H
24.30
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480098
2"
CWR
011
037303
101CS1P
011-TZV-0004
AT GRADE
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
108.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480109
2"
CWR
011
042001
101CS1P
011-TZV-0006
AT GRADE
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
93.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
-1.00
80.00
80.00
MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. NOTE 10 MAX.TEMPERATURE FOR THERMAL EXPANSION:80ºC.
MAX.TEMPERATURE FOR THERMAL EXPANSION 80°C -
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 60ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 60ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 60ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 60ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 65 ºC. NOTE 10
Page 57 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7) MAX. TEMPERATURE FOR THERMAL EXPANSION: 65 ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 65 ºC. NOTE 10
SA-JER-DS011-TRJR-480109
2"
CWR
011
042002
101CS1P
2"-CWR-011042301-101CS1P-N
Reducer
-
-
N
-
SOFT CW
Liquid
992
4.00
41.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480109
1"
CWR
011
042002
101CS1P
Reducer
011-TZV-0006
-
-
N
-
SOFT CW
Liquid
992
4.00
41.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480109
12"
CWR
011
042301
101CS1P
011-E-0033
12"-CWR-011072303-301FE0WN
-
-
N
-
SOFT CW
Liquid
992
4.00
41.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 65 ºC.
SA-JER-DS011-TRJR-480109
2"
CWR
011
042301
101CS1P 12"-CWR-011042301-101CS1P-N 2"-CWR-011042002-101CS1P-N
-
-
N
-
SOFT CW
Liquid
992
4.00
41.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 65 ºC. NOTE 10
SA-JER-DS011-TRJR-480207
40"
CWR
011
072301
301FE0W
Cap
IP-6041-S
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
2"
CWR
011
072301
301FE0W
40"-CWR-011072301-301FE0WN
011-SC-0047
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480273
1/2"
CWR
011
072301
301FE0W
Reducer
SO
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
-
-
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
18"
CWR
011
072302
301FE0W 18"-CWR-011098301-101CS1P-N
40"-CWR-011072301-301FE0WN
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480109
12"
CWR
011
072303
301FE0W 12"-CWR-011042301-101CS1P-N
SA-JER-DS011-TRJR-480207
-
-
N
-
SOFT CW
Liquid
992
4.00
41.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 65 ºC.
SA-JER-DS011-TRJR-480207
12"
CWR
011
072303
301FE0W
SA-JER-DS011-TRJR-480109
40"-CWR-011072301-301FE0WN
-
-
N
-
SOFT CW
Liquid
990
4.00
41.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480060
6"
CWR
011
072304
301FE0W
6"-CWR-011025302-101CS1P-N
SA-JER-DS011-TRJR-480207
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
6"
CWR
011
072304
301FE0W
SA-JER-DS011-TRJR-480060
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
6"
CWR
011
072305
301FE0W
SA-JER-DS011-TRJR-480062
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480062
6"
CWR
011
072305
301FE0W
6"-CWR-011025303-101CS1P-N
SA-JER-DS011-TRJR-480207
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480098
4"
CWR
011
072306
301FE0W
4"-CWR-011037301-101CS1P-N
SA-JER-DS011-TRJR-480207
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
4"
CWR
011
072306
301FE0W
SA-JER-DS011-TRJR-480098
40"-CWR-011072301-301FE0WN
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480058
10"
CWR
011
072307
301F0W
10"-CWR-011025301-101CS1P-N
SA-JER-DS011-TRJR-480207
-
-
N
-
SOFT CW
Liquid
990
4.00
43.00
-
-
11.00
80.00
-
-
-
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
10"
CWR
011
072307
-
-
N
-
SOFT CW
Liquid
990
4.00
43.00
-
-
11.00
80.00
-
-
-
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
12"
CWR
011
072308
-
-
N
-
SOFT CW
Liquid
990
4.00
42.00
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
28"
CWR
011
072309
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
4"
CWR
011
072312
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
6"
CWR
011
072313
40"-CWR-011072301-301FE0WN 40"-CWR-011072301-301FE0W301FE0W 12"-CWR-011020301-101CS1P-N N 40"-CWR-011072301-301FE0W301FE0W 28"-CWR-011032301-101CS1P-N N 40"-CWR-011072301-301FE0W301FE0W 4"-CWR-011035302-101CS1P-N N 101CS1P FUTURE CONNECTION 6"-CWR-011072313-301FE0W-N
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
6"
CWR
011
072313
301FE0W
6"-CWR-011072313-101CS1P-N
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
6"
CWR
011
072314
301FE0W
6"-CWR-011072314-101CS1P-N
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
6"
CWR
011
072314
101CS1P
FUTURE CONNECTION
6"-CWR-011072314-301FE0W-N
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
3"
CWR
011
080302
301FE0W
3"-CWR-011035301-101CS1P-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
6"
CWR
011
080302
301FE0W
Reducer
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
6"
CWR
011
080302
301FE0W
SA-JER-DS011-TRJR-480240
8"-CWR-011080302-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
8"
CWR
011
080302
301FE0W
8"-CWR-011171395-301FE0W-N
SA-JER-DS011-TRJR-480237
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
8"
CWR
011
080302
301FE0W
SA-JER-DS011-TRJR-480239
IP-6039-S
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480136
14"
CWR
011
098001
103CS1P
011-E-0037-A
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
23.00
80.00
-
H
34.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 82ºC.
SA-JER-DS011-TRJR-480136
18"
CWR
011
098001
103CS1P
Reducer
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
23.00
80.00
-
H
34.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480136
12"
CWR
011
098001
103CS1P
Reducer
011-HV-0018
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
23.00
80.00
-
H
34.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
301F0W
40"-CWR-011072301-301FE0WN 40"-CWR-011072301-301FE0WN
SA-JER-DS011-TRJR-480058
SA-JER-DS011-TRJR-480136
2"
CWR
011
098002
103CS1P 14"-CWR-011098001-103CS1P-N
SA-JER-DS011-TRJR-480136
1"
CWR
011
098002
103CS1P
SA-JER-DS011-TRJR-480136
2"
CWR
011
098004
103CS1P 14"-CWR-011098001-103CS1P-N
SA-JER-DS011-TRJR-480136
1"
CWR
011
098004
103CS1P
SA-JER-DS011-TRJR-480136
2"
CWR
011
098005
SA-JER-DS011-TRJR-480136
3"
CWR
011
SA-JER-DS011-TRJR-480136
2"
CWR
SA-JER-DS011-TRJR-480136
3"
SA-JER-DS011-TRJR-480136
40"-CWR-011072301-301FE0WN 40"-CWR-011072301-301FE0WN
MAX. TEMPERATURE FOR THERMAL EXPANSION: 82ºC. MAX. TEMPERATURE FOR THERMAL EXPANSION: 82ºC. MAX. TEMPERATURE FOR THERMAL EXPANSION: 82ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 82ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 82ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 82ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 82ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 82ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 82ºC. NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 82ºC. NOTE 10 -
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
23.00
80.00
-
H
34.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
011-TZV-0015
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
23.00
80.00
-
H
34.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
23.00
80.00
-
H
34.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
Reducer
011-TZV-0016
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
23.00
80.00
-
H
34.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
101CS1P
011-TZV-0016
Reducer
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
108.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
098005
101CS1P
Reducer
ATM
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
108.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
011
098006
101CS1P
011-TZV-0015
Reducer
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
108.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
CWR
011
098006
101CS1P
Reducer
ATM
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
108.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
12"
CWR
011
098301
101CS1P
011-HV-0018
Reducer
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480136
18"
CWR
011
098301
101CS1P
Reducer
SA-JER-DS011-TRJR-480207
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
18"
CWR
011
098301
101CS1P
SA-JER-DS011-TRJR-480136
18"-CWR-011072302-301FE0WN
-
-
N
-
SOFT CW
Liquid
990
4.00
46.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480249
3/4"
CWR
011
171301
101CS1P
011-G-0026-A
SA-JER-DS011-TRJR-480237
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
3/4"
CWR
011
171301
101CS1P
SA-JER-DS011-TRJR-480249
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
2"
CWR
011
171301
101CS1P
Reducer
2"-CWR-011171348-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480249
3/4"
CWR
011
171302
101CS1P
011-G-0026-B
SA-JER-DS011-TRJR-480237
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
3/4"
CWR
011
171302
101CS1P
SA-JER-DS011-TRJR-480249
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
2"
CWR
011
171302
101CS1P
Reducer
2"-CWR-011171347-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
1"
CWR
011
171305
101CS1P
011-G-0002-A
SA-JER-DS011-TRJR-480237
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
1"
CWR
011
171305
101CS1P
SA-JER-DS011-TRJR-480245
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
2"
CWR
011
171305
101CS1P
Reducer
2"-CWR-011171352-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
1"
CWR
011
171306
101CS1P
011-G-0002-B
SA-JER-DS011-TRJR-480237
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
1"
CWR
011
171306
101CS1P
SA-JER-DS011-TRJR-480245
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
2"
CWR
011
171306
101CS1P
Reducer
2"-CWR-011171351-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
3/4"
CWR
011
171307
101CS1P
011-G-0028-A
SA-JER-DS011-TRJR-480238
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
3/4"
CWR
011
171307
101CS1P
SA-JER-DS011-TRJR-480250
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWR
011
171307
101CS1P
Reducer
2"-CWR-011171354-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
3/4"
CWR
011
171308
101CS1P
011-G-0028-B
SA-JER-DS011-TRJR-480238
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
3/4"
CWR
011
171308
101CS1P
SA-JER-DS011-TRJR-480250
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWR
011
171308
101CS1P
Reducer
2"-CWR-011171353-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
3/4"
CWR
011
171309
101CS1P
011-G-0024-A
SA-JER-DS011-TRJR-480238
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWR
011
171309
101CS1P
Reducer
2"-CWR-011171356-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
3/4"
CWR
011
171309
101CS1P
SA-JER-DS011-TRJR-480250
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
3/4"
CWR
011
171310
101CS1P
011-G-0024-B
SA-JER-DS011-TRJR-480238
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWR
011
171310
101CS1P
Reducer
2"-CWR-011171355-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
3/4"
CWR
011
171310
101CS1P
SA-JER-DS011-TRJR-480250
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480249
3/4"
CWR
011
171313
101CS1P
011-G-0025-A
SA-JER-DS011-TRJR-480238
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWR
011
171313
101CS1P
Reducer
2"-CWR-011171360-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
3/4"
CWR
011
171313
101CS1P
SA-JER-DS011-TRJR-480249
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480251
3/4"
CWR
011
171315
101CS1P
011-G-0003-A
SA-JER-DS011-TRJR-480238
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
3/4"
CWR
011
171315
101CS1P
SA-JER-DS011-TRJR-480251
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWR
011
171315
101CS1P
Reducer
2"-CWR-011171362-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480251
3/4"
CWR
011
171316
101CS1P
011-G-0003-B
SA-JER-DS011-TRJR-480238
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
3/4"
CWR
011
171316
101CS1P
SA-JER-DS011-TRJR-480251
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWR
011
171316
101CS1P
Reducer
2"-CWR-011171361-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
1"
CWR
011
171317
101CS1P
011-G-0004-A
SA-JER-DS011-TRJR-480238
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
1"
CWR
011
171317
101CS1P
SA-JER-DS011-TRJR-480245
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWR
011
171317
101CS1P
Reducer
2"-CWR-011171364-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
1"
CWR
011
171318
101CS1P
011-G-0004-B
SA-JER-DS011-TRJR-480238
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
1"
CWR
011
171318
101CS1P
SA-JER-DS011-TRJR-480245
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWR
011
171318
101CS1P
Reducer
2"-CWR-011171363-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480252
1-1/2"
CWR
011
171319
101CS1P
011-G-0008-A
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171319
101CS1P
Reducer
2"-CWR-011171365-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
Reducer
Page 58 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
INSULATION (NOTE 2)
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480239
1-1/2"
CWR
011
171319
101CS1P
SA-JER-DS011-TRJR-480252
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480252
1-1/2"
CWR
011
171320
101CS1P
011-G-0008-B
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171320
101CS1P
Reducer
2"-CWR-011171366-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1-1/2"
CWR
011
171320
101CS1P
SA-JER-DS011-TRJR-480252
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480253
1"
CWR
011
171321
101CS1P
011-G-0005-A
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171321
101CS1P
Reducer
2"-CWR-011171367-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1"
CWR
011
171321
101CS1P
SA-JER-DS011-TRJR-480253
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480253
1"
CWR
011
171322
101CS1P
011-G-0005-B
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171322
101CS1P
Reducer
2"-CWR-011171368-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1"
CWR
011
171322
101CS1P
SA-JER-DS011-TRJR-480253
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480246
2"
CWR
011
171323
101CS1P
011-G-0010-A
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171323
101CS1P
SA-JER-DS011-TRJR-480246
2"-CWR-011171369-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480246
2"
CWR
011
171324
101CS1P
011-G-0010-B
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171324
101CS1P
SA-JER-DS011-TRJR-480246
2"-CWR-011171370-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
1"
CWR
011
171325
101CS1P
011-G-0007-A
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1"
CWR
011
171325
101CS1P
SA-JER-DS011-TRJR-480245
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171325
101CS1P
Reducer
2"-CWR-011171372-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
1"
CWR
011
171326
101CS1P
011-G-0007-B
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1"
CWR
011
171326
101CS1P
SA-JER-DS011-TRJR-480245
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171326
101CS1P
Reducer
2"-CWR-011171371-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480263
2"
CWR
011
171327
101CS1P
011-G-0012-A
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171327
101CS1P
SA-JER-DS011-TRJR-480263
2"-CWR-011171373-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480263
2"
CWR
011
171328
101CS1P
011-G-0012-B
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171328
101CS1P
SA-JER-DS011-TRJR-480263
2"-CWR-011171374-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480247
2"
CWR
011
171329
101CS1P
011-G-0014-A
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171329
101CS1P
SA-JER-DS011-TRJR-480247
2"-CWR-011171375-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480247
2"
CWR
011
171330
101CS1P
011-G-0014-B
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171330
101CS1P
SA-JER-DS011-TRJR-480247
2"-CWR-011171376-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
1-1/2"
CWR
011
171331
101CS1P
011-G-0013-A
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1-1/2"
CWR
011
171331
101CS1P
SA-JER-DS011-TRJR-480250
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171331
101CS1P
Reducer
2"-CWR-011171378-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
1-1/2"
CWR
011
171332
101CS1P
011-G-0013-B
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1-1/2"
CWR
011
171332
101CS1P
SA-JER-DS011-TRJR-480250
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171332
101CS1P
Reducer
2"-CWR-011171377-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480247
2"
CWR
011
171333
101CS1P
011-G-0018-A
SA-JER-DS011-TRJR-480240
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171333
101CS1P
SA-JER-DS011-TRJR-480247
2"-CWR-011171379-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480247
2"
CWR
011
171334
101CS1P
011-G-0018-B
SA-JER-DS011-TRJR-480240
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171334
101CS1P
SA-JER-DS011-TRJR-480247
2"-CWR-011171380-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
1"
CWR
011
171335
101CS1P
011-G-0017-A
SA-JER-DS011-TRJR-480240
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
1"
CWR
011
171335
101CS1P
SA-JER-DS011-TRJR-480245
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171335
101CS1P
Reducer
2"-CWR-011171381-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
1"
CWR
011
171336
101CS1P
011-G-0017-B
SA-JER-DS011-TRJR-480240
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
1"
CWR
011
171336
101CS1P
SA-JER-DS011-TRJR-480245
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171336
101CS1P
Reducer
2"-CWR-011171382-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480247
1"
CWR
011
171337
101CS1P
011-G-0016-A
SA-JER-DS011-TRJR-480240
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171337
101CS1P
Reducer
2"-CWR-011171383-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
1"
CWR
011
171337
101CS1P
SA-JER-DS011-TRJR-480247
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480247
1"
CWR
011
171338
101CS1P
011-G-0016-B
SA-JER-DS011-TRJR-480240
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171338
101CS1P
Reducer
2"-CWR-011171384-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
1"
CWR
011
171338
101CS1P
SA-JER-DS011-TRJR-480247
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480253
1-1/2"
CWR
011
171339
101CS1P
011-G-0015-A
SA-JER-DS011-TRJR-480240
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171339
101CS1P
Reducer
2"-CWR-011171385-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
1-1/2"
CWR
011
171339
101CS1P
SA-JER-DS011-TRJR-480253
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480253
1-1/2"
CWR
011
171340
101CS1P
011-G-0015-B
SA-JER-DS011-TRJR-480240
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171340
101CS1P
Reducer
2"-CWR-011171386-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
1-1/2"
CWR
011
171340
101CS1P
SA-JER-DS011-TRJR-480253
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480248
3/4"
CWR
011
171341
101CS1P
011-G-0020-A
SA-JER-DS011-TRJR-480240
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
3/4"
CWR
011
171341
101CS1P
SA-JER-DS011-TRJR-480248
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171341
101CS1P
Reducer
2"-CWR-011171387-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480248
3/4"
CWR
011
171342
101CS1P
011-G-0020-B
SA-JER-DS011-TRJR-480240
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
3/4"
CWR
011
171342
101CS1P
SA-JER-DS011-TRJR-480248
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171342
101CS1P
Reducer
2"-CWR-011171388-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480252
1-1/2"
CWR
011
171343
101CS1P
011-G-0009-A
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1-1/2"
CWR
011
171343
101CS1P
SA-JER-DS011-TRJR-480252
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171343
101CS1P
Reducer
2"-CWR-011171390-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480252
1-1/2"
CWR
011
171344
101CS1P
011-G-0009-B
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1-1/2"
CWR
011
171344
101CS1P
SA-JER-DS011-TRJR-480252
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171344
101CS1P
Reducer
2"-CWR-011171389-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
1-1/2"
CWR
011
171345
101CS1P
011-G-0011-A
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1-1/2"
CWR
011
171345
101CS1P
SA-JER-DS011-TRJR-480250
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171345
101CS1P
Reducer
2"-CWR-011171392-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
1-1/2"
CWR
011
171346
101CS1P
011-G-0011-B
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171346
101CS1P
Reducer
2"-CWR-011171391-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1-1/2"
CWR
011
171346
101CS1P
SA-JER-DS011-TRJR-480250
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
2"
CWR
011
171347
301FE0W
2"-CWR-011171302-101CS1P-N
2"-CWR-011171348-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
2"
CWR
011
171348
301FE0W
2"-CWR-011171301-101CS1P-N
8"-CWR-011080302-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
2"
CWR
011
171351
301FE0W
2"-CWR-011171306-101CS1P-N
3"-CWR-011171352-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
3"
CWR
011
171352
301FE0W
HEADER
8"-CWR-011080302-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
2"
CWR
011
171352
301FE0W
2"-CWR-011171305-101CS1P-N
3"-CWR-011171352-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWR
011
171353
301FE0W
2"-CWR-011171308-101CS1P-N
3"-CWR-011171393-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWR
011
171354
301FE0W
2"-CWR-011171307-101CS1P-N
3"-CWR-011171393-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWR
011
171355
301FE0W
2"-CWR-011171310-101CS1P-N
3"-CWR-011171393-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWR
011
171356
301FE0W
2"-CWR-011171309-101CS1P-N
3"-CWR-011171393-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWR
011
171360
301FE0W
2"-CWR-011171313-101CS1P-N
3"-CWR-011171393-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWR
011
171361
301FE0W
2"-CWR-011171316-101CS1P-N
6"-CWR-011171393-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWR
011
171362
301FE0W
2"-CWR-011171315-101CS1P-N
6"-CWR-011171393-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWR
011
171363
301FE0W
2"-CWR-011171318-101CS1P-N
6"-CWR-011171393-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWR
011
171364
301FE0W
2"-CWR-011171317-101CS1P-N
6"-CWR-011171393-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171365
301FE0W
2"-CWR-011171319-101CS1P-N
6"-CWR-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171366
301FE0W
2"-CWR-011171320-101CS1P-N
6"-CWR-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171367
301FE0W
2"-CWR-011171321-101CS1P-N
6"-CWR-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
Page 59 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480239
2"
CWR
011
171368
301FE0W
2"-CWR-011171322-101CS1P-N
6"-CWR-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171369
301FE0W
2"-CWR-011171323-101CS1P-N
6"-CWR-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171370
301FE0W
2"-CWR-011171324-101CS1P-N
6"-CWR-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171371
301FE0W
2"-CWR-011171326-101CS1P-N
8"-CWR-011080302-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171372
301FE0W
2"-CWR-011171325-101CS1P-N
8"-CWR-011080302-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171373
301FE0W
2"-CWR-011171327-101CS1P-N
6"-CWR-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171374
301FE0W
2"-CWR-011171328-101CS1P-N
6"-CWR-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171375
301FE0W
2"-CWR-011171329-101CS1P-N
6"-CWR-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171376
301FE0W
2"-CWR-011171330-101CS1P-N
6"-CWR-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171377
301FE0W
2"-CWR-011171332-101CS1P-N
8"-CWR-011080302-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171378
301FE0W
2"-CWR-011171331-101CS1P-N
8"-CWR-011080302-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171379
301FE0W
2"-CWR-011171333-101CS1P-N
6"-CWR-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171380
301FE0W
2"-CWR-011171334-101CS1P-N
6"-CWR-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171381
301FE0W
2"-CWR-011171335-101CS1P-N
6"-CWR-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171382
301FE0W
2"-CWR-011171336-101CS1P-N
6"-CWR-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171383
301FE0W
2"-CWR-011171337-101CS1P-N
2"-CWR-011171384-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171384
301FE0W
2"-CWR-011171338-101CS1P-N
6"-CWR-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171385
301FE0W
2"-CWR-011171339-101CS1P-N
6"-CWR-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171386
301FE0W
2"-CWR-011171340-101CS1P-N
6"-CWR-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171387
301FE0W
2"-CWR-011171341-101CS1P-N
6"-CWR-011080302-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171388
301FE0W
2"-CWR-011171342-101CS1P-N
6"-CWR-011080302-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171389
301FE0W
2"-CWR-011171344-101CS1P-N
8"-CWR-011080302-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171390
301FE0W
2"-CWR-011171343-101CS1P-N
8"-CWR-011080302-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171391
301FE0W
2"-CWR-011171346-101CS1P-N
6"-CWR-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWR
011
171392
301FE0W
2"-CWR-011171345-101CS1P-N
6"-CWR-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
6"
CWR
011
171393
301FE0W
HEADER
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
3"
CWR
011
171393
301FE0W
Reducer
HEADER
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
3"
CWR
011
171393
301FE0W
3"-CWR-011171393-301FE0W-N
HEADER
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
6"
CWR
011
171395
301FE0W
HEADER
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
6"
CWR
011
171395
301FE0W
SA-JER-DS011-TRJR-480240
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
8"
CWR
011
171395
301FE0W
Reducer
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
6"
CWR
011
171395
301FE0W
SA-JER-DS011-TRJR-480238
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
6"
CWR
011
171395
301FE0W
6"-CWR-011171393-301FE0W-N
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171397
301FE0W
2"-CWR-011171398-101CS1P-N
6"-CWR-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480251
3/4"
CWR
011
171398
101CS1P
011-G-0027
SA-JER-DS011-TRJR-480240
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
3/4"
CWR
011
171398
101CS1P
SA-JER-DS011-TRJR-480251
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWR
011
171398
101CS1P
Reducer
2"-CWR-011171397-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480290
1"
CWR
011
230302
101CS1P
011-AS-0002
SA-JER-DS011-TRJR-480238
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWR
011
230302
101CS1P
Reducer
2"-CWR-011230305-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
1"
CWR
011
230302
101CS1P
SA-JER-DS011-TRJR-480290
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
2"
CWR
011
230304
301FE0W
HEADER
8"-CWR-011080302-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWR
011
230305
301FE0W
2"-CWR-011230302-101CS1P-N
3"-CWR-011171393-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1"
CWR
011
405301
101CS1P
1"-CWR-011405302-101CS1P-N
SA-JER-DS011-TRJR-480240
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
1"
CWR
011
405301
101CS1P
SA-JER-DS011-TRJR-480267
3"-CWR-011525301-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1"
CWR
011
405302
101CS1P
011-E-0048-A
Reducer
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480267
4"
CWR
011
405302
101CS1P
Reducer
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480267
1"
CWR
011
405302
101CS1P
Reducer
1"-CWR-011405301-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480267
1"
CWR
011
405302
101CS1P
011-E-0048-B
1"-CWR-011405302-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480267
1"
CWR
011
405303
101CS1P
1"-CWR-011405302-101CS1P-N
011-TZV-0498
-
-
N
-
AIR
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480267
1"
CWR
011
405304
101CS1P
011-TZV-0498
AT GRADE.AT SAFE LOCATION
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
55.00
-
Visual Test
0.00
ASME N/A
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480267
1"
CWR
011
405305
101CS1P
1"-CWR-011405302-101CS1P-N
011-TZV-0497
-
-
N
-
AIR
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480267
1"
CWR
011
405306
101CS1P
011-TZV-0497
AT GRADE.AT SAFE LOCATION
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
55.00
-
Visual Test
0.00
ASME N/A
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
1-1/2"
CWR
011
446301
101CS1P
N6
SA-JER-DS011-TRJR-480237
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
1-1/2"
CWR
011
446301
101CS1P
SA-JER-DS011-TRJR-480254
2"-CWR-011446301-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
2"
CWR
011
446301
101CS1P
HEADER
2"-CWR-011446307-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480254
1-1/2"
CWR
011
446302
101CS1P
011-E-0044-A
N6
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
1-1/2"
CWR
011
446302
101CS1P
011-E-0044-B
1-1/2"-CWR-011446302-101CS1PN
SA-JER-DS011-TRJR-480254
1"
CWR
011
446303
101CS1P
1-1/2"-CWR-011446302101CS1P-N
011-TZV-0604
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
SA-JER-DS011-TRJR-480254
2"
CWR
011
446304
101CS1P
011-TZV-0604
AT GRADE
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
50.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480254
1"
CWR
011
446305
101CS1P
1-1/2"-CWR-011446302101CS1P-N
011-TZV-0605
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
2"
CWR
011
446306
101CS1P
011-TZV-0605
AT GRADE
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
50.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
2"
CWR
011
446307
301FE0W
2"-CWR-011446301-101CS1P-N
8"-CWR-011080302-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
2"-CWR-011450301-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480256
1-1/2"
CWR
011
450301
101CS1P
1-1/2"-CWR-011450303101CS1P-N
SA-JER-DS011-TRJR-480237
1-1/2"
CWR
011
450301
101CS1P
SA-JER-DS011-TRJR-480256
SA-JER-DS011-TRJR-480237
2"
CWR
011
450301
101CS1P
HEADER
2"-CWR-011450302-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480237
2"
CWR
011
450302
301FE0W
2"-CWR-011450301-101CS1P-N
3"-CWR-011171352-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
1-1/2"-CWR-011450301-101CS1PN 1-1/2"-CWR-011450303-101CS1PN
SA-JER-DS011-TRJR-480256
1-1/2"
CWR
011
450303
101CS1P
SA-JER-DS011-TRJR-480256
1-1/2"
CWR
011
450303
101CS1P
011-E-0045-B
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
2"
CWR
011
450304
101CS1P
011-TZV-0655
AT GRADE AT SAFE LOCATION
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
50.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480256
2"
CWR
011
450305
101CS1P
011-TZV-0654
AT GRADE AT SAFE LOCATION
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
50.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
011-TZV-0655
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
011-E-0045-A
1-1/2"-CWR-011450303101CS1P-N 1-1/2"-CWR-011450303101CS1P-N
1"
CWR
011
450306
101CS1P
SA-JER-DS011-TRJR-480256
1"
CWR
011
450307
101CS1P
011-TZV-0654
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
1-1/2"
CWR
011
460301
101CS1P
N6
SA-JER-DS011-TRJR-480238
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
3"
CWR
011
460301
101CS1P
HEADER
3"-CWR-011460302-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
3"
CWR
011
460302
301FE0W
3"-CWR-011460301-101CS1P-N
6"-CWR-011171393-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480258
1-1/2"
CWR
011
460303
101CS1P
011-E-0046-A
N6
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
1-1/2"
CWR
011
460303
101CS1P
011-E-0046-B
1-1/2"-CWR-011460303-101CS1PN
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
1"
CWR
011
460304
101CS1P
011-TZV-0704
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
1"
CWR
011
460305
101CS1P
011-TZV-0705
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
2"
CWR
011
460306
101CS1P
011-TZV-0705
AT GRADE
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
50.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480258
2"
CWR
011
460307
101CS1P
011-TZV-0704
AT GRADE
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
50.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480260
1-1/2"
CWR
011
525301
101CS1P
N6
SA-JER-DS011-TRJR-480240
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
3"
CWR
011
525301
101CS1P
HEADER
3"-CWR-011525308-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
1-1/2"
CWR
011
525301
101CS1P
SA-JER-DS011-TRJR-480260
3"-CWR-011525301-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480260
1-1/2"
CWR
011
525302
101CS1P
011-E-0047-A
N6
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480260
1-1/2"
CWR
011
525302
101CS1P
011-E-0047-B
1-1/2"-CWR-011525302-101CS1PN
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480260
3/4"
CWR
011
525304
101CS1P
1-1/2"-CWR-011525302101CS1P-N
011-TZV-0754
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
SA-JER-DS011-TRJR-380001
1-1/2"-CWR-011460303101CS1P-N 1-1/2"-CWR-011460303101CS1P-N
Page 60 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
(ºC)
TEST CONDITIONS
MEDIUM (NOTE 5)
PRESS. (BARG)
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6)
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480260
3/4"
CWR
011
525305
101CS1P
1-1/2"-CWR-011525302101CS1P-N
011-TZV-0755
-
-
N
-
AUXILIARY CW
Liquid
990
3.00
45.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480260
1"
CWR
011
525306
101CS1P
011-TZV-0754
AT GRADE
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
50.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480260
1"
CWR
011
525307
101CS1P
011-TZV-0755
AT GRADE
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
50.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480240
3"
CWR
011
525308
301FE0W
3"-CWR-011525301-101CS1P-N
6"-CWR-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
990.3
3.00
45.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
012002
101CH2S
2"-SRW-011012001-101CH2S-P
SAMPLE COOLER
-
-
P
25
SOUR WATER
Liquid
970
3.80
110.00
-
-
6.50
140.00
-
H
9.75
D
YES
M
N
N
N
Y
N
N
-
THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. NOTE 6. THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
012003
101CH2S
3/4"-CWS-011200001-101CH2SN
2"-SRW-011012001-101CH2S-P
-
-
P
25
SOUR WATER
Liquid
970
1.30
110.00
-
-
6.00
140.00
-
H
9.00
D
YES
M
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
012003
101CH2S
3/4"-CWS-011012003-101CH2SP
Reducer
-
-
P
25
SOUR WATER
Liquid
970
1.30
110.00
-
-
6.00
140.00
-
H
9.00
D
YES
M
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/2"
CWS
011
012003
101CH2S
Reducer
Reducer
-
-
P
25
SOUR WATER
Liquid
970
1.30
110.00
-
-
6.00
140.00
-
H
9.00
D
YES
M
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
012003
101CH2S
Reducer
3/4"-LFL-011200307-101CH2F-N
-
-
P
25
SOUR WATER
Liquid
970
1.30
110.00
-
-
6.00
140.00
-
H
9.00
D
YES
M
N
N
N
Y
N
N
-
NOTE 6.
Plug
-
-
P
25
SOUR WATER
Liquid
970
1.30
110.00
-
-
6.00
140.00
-
H
9.00
D
YES
M
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
012003
101CH2S
3/4"-CWS-011012003-101CH2SP
SA-JER-DS011-TRJR-480275
1/4"
CWS
011
012003
101CH2S
SAMPLE CYLINDER
Reducer
-
-
P
25
SOUR WATER
Liquid
970
1.30
110.00
-
-
6.00
140.00
-
-
-
D
YES
M
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/2"
CWS
011
012003
101CH2S
Reducer
1/2"-CWS-011012003-101CH2SP
-
-
P
25
SOUR WATER
Liquid
970
1.30
110.00
-
-
6.00
140.00
-
H
9.00
D
YES
M
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480238
2"
CWS
011
012301
101CS1P
2"-CWS-011171316-101CS1P-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
1"
CWS
011
012301
101CS1P
Reducer
SA-JER-DS011-TRJR-480023
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480023
1"
CWS
011
012301
101CS1P
SA-JER-DS011-TRJR-480238
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480023
1/2"
CWS
011
012301
101CS1P
Reducer
Flange
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
-
P
25
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
-
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
019006
101CH2S
6"-SRW-011019001-101CH2S-P
SAMPLE COOLER
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
019008
101CH2S
3/4"-CWS-011200002-101CH2SN
6"-SRW-011019001-101CH2S-P
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
019008
101CH2S
3/4"-CWS-011019008-101CH2SP
Reducer
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/2"
CWS
011
019008
101CH2S
Reducer
Reducer
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
019008
101CH2S
Reducer
3/4"-LFL-011200308-101CH2F-N
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6.
Plug
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6.
SOUR WATER
Liquid
-
THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. NOTE 6. THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
019008
101CH2S
3/4"-CWS-011019008-101CH2SP
SA-JER-DS011-TRJR-480275
1/4"
CWS
011
019008
101CH2S
SAMPLE CYLINDER
Reducer
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
-
-
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/2"
CWS
011
019008
101CH2S
Reducer
1/2"-CWS-011019008-101CH2SP
-
-
P
25
SOUR WATER
Liquid
981
1.02
170.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480207
12"
CWS
011
020301
101CS1P
12"-CWS-011072308-301FE0WN
SA-JER-DS011-TRJR-480049
-
-
N
-
SOFT CW
Liquid
994
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480049
12"
CWS
011
020301
101CS1P
SA-JER-DS011-TRJR-480207
Reducer
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480049
16"
CWS
011
020301
101CS1P
Reducer
011-E-0021
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480275
4"
CWS
011
021002
101CH2S
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
021002
THIS LINE IS ALREADY DRAW IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. NOTE 6. THIS LINE IS ALREADY DRAW IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. NOTE 6.
Reducer
Reducer
-
-
N
-
SOUR WATER
Liquid
991
2.60
43.00
-
-
7.00
95.00
-
H
10.50
D
YES
A or Q
N
N
N
Y
N
N
-
101CH2S
Reducer
3/4"-CWS-011021003-101CH2SN
-
-
N
-
SOUR WATER
Liquid
991
2.60
43.00
-
-
7.00
95.00
-
H
10.50
D
YES
A or Q
N
N
N
Y
N
N
-
Reducer
-
-
N
-
SOUR WATER
Liquid
991
2.60
43.00
-
-
7.00
95.00
-
H
10.50
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
Reducer
-
-
N
-
SOUR WATER
Liquid
991
2.60
43.00
-
-
7.00
95.00
-
H
10.50
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
-
N
-
SOUR WATER
Liquid
991
2.60
43.00
-
-
7.00
95.00
-
-
-
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
021002
101CH2S
3/4"-CWS-011021002-101CH2SN
SA-JER-DS011-TRJR-480275
1/2"
CWS
011
021002
101CH2S
Reducer
SA-JER-DS011-TRJR-480275
1/4"
CWS
011
021002
101CH2S
Reducer
SAMPLE CYLINDER
-
Reducer
-
-
N
-
SOUR WATER
Liquid
991
1.20
43.00
-
-
5.00
95.00
-
H
7.50
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
Reducer
-
-
N
-
SOUR WATER
Liquid
991
1.20
43.00
-
-
5.00
95.00
-
H
7.50
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
021003
101CH2S
3/4"-CWS-011021003-101CH2SN
SA-JER-DS011-TRJR-480275
1/2"
CWS
011
021003
101CH2S
Reducer
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
021003
101CH2S
Reducer
Reducer
-
-
N
-
SOUR WATER
Liquid
991
1.20
43.00
-
-
5.00
95.00
-
H
7.50
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
2"
CWS
011
021003
101CH2S
Reducer
2"-CLD-011200310-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
991
1.20
43.00
-
-
5.00
95.00
-
H
7.50
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/4"
CWS
011
021003
101CH2S
SAMPLE CYLINDER
Reducer
-
-
N
-
SOUR WATER
Liquid
991
1.20
43.00
-
-
5.00
95.00
-
-
-
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/2"
CWS
011
021003
101CH2S
Reducer
1/2"-CWS-011021003-101CH2SN
-
-
N
-
SOUR WATER
Liquid
991
1.20
43.00
-
-
5.00
95.00
-
H
7.50
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480207
10"
CWS
011
025301
101CS1P
10"-CWS-011072307-301FE0WN
SA-JER-DS011-TRJR-480058
-
-
N
-
SOFT CW
Liquid
994
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480058
10"
CWS
011
025301
101CS1P
SA-JER-DS011-TRJR-480207
10"-CWS-011025301-101CS1P-N
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480058
10"
CWS
011
025301
101CS1P 10"-CWS-011025301-101CS1P-N
Reducer
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
14.10
80.00
-
H
21.15
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480058
12"
CWS
011
025301
101CS1P
Reducer
011-E-0023
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
14.10
80.00
-
H
21.15
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
6"
CWS
011
025302
101CS1P
6"-CWS-011072304-301FE0W-N
SA-JER-DS011-TRJR-480060
-
-
N
-
SOFT CW
Liquid
994
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480060
6"
CWS
011
025302
101CS1P
6"-CWS-011025302-101CS1P-N
011-E-0034
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
15.40
80.00
-
H
23.10
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480060
6"
CWS
011
025302
101CS1P
SA-JER-DS011-TRJR-480207
6"-CWS-011025302-101CS1P-N
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
6"
CWS
011
025303
101CS1P
6"-CWS-011072305-301FE0W-N
SA-JER-DS011-TRJR-480062
-
-
N
-
SOFT CW
Liquid
994
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480062
6"
CWS
011
025303
101CS1P
SA-JER-DS011-TRJR-480207
6"-CWS-011025303-101CS1P-N
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480062
6"
CWS
011
025303
101CS1P
6"-CWS-011025303-101CS1P-N
011-E-0035
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
15.40
80.00
-
H
23.10
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. NOTE 10.
SA-JER-DS011-TRJR-480082
2"
CWS
011
031001
101CS1P 28"-CWS-011031301-101CS1P-N
SA-JER-DS011-TRJR-480082
1"
CWS
011
031001
101CS1P
SA-JER-DS011-TRJR-480082
14"
CWS
011
031002
101CS1P 28"-CWS-011031301-101CS1P-N
SA-JER-DS011-TRJR-480082
16"
CWS
011
031002
101CS1P
SA-JER-DS011-TRJR-480082
14"
CWS
011
031003
101CS1P 28"-CWS-011031301-101CS1P-N
SA-JER-DS011-TRJR-480082
16"
CWS
011
031003
101CS1P
SA-JER-DS011-TRJR-480083
14"
CWS
011
031004
101CS1P 28"-CWS-011031301-101CS1P-N
SA-JER-DS011-TRJR-480083
16"
CWS
011
031004
101CS1P
SA-JER-DS011-TRJR-480083
14"
CWS
011
031005
101CS1P 28"-CWS-011031301-101CS1P-N
SA-JER-DS011-TRJR-480083
16"
CWS
011
031005
101CS1P
Reducer
Reducer
Reducer
Reducer
Reducer
Reducer
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
11.00
-1.00
80.00
80.00
-1.00
80.00
80.00
-
H
NFS
By Code
A or Q
N
N
N
N
N
011-TZV-0014
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
11.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC.
Reducer
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
011-E-0025-A/B
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
Reducer
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
011-E-0025-B
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
Reducer
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
11.00
-1.00
80.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC.
011-E-0025-C
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
11.00
-1.00
80.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC.
Reducer
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
11.00
-1.00
80.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
011-E-0025-D
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
11.00
-1.00
80.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480082
2"
CWS
011
031006
101CS1P
011-TZV-0014
AT GRADE
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
SA-JER-DS011-TRJR-480207
28"
CWS
011
031301
101CS1P
28"-CWS-011072309-301FE0WN
SA-JER-DS011-TRJR-480082
-
-
N
-
SOFT CW
Liquid
994
6.00
36.50
-
-
11.00
-1.00
80.00
SA-JER-DS011-TRJR-480082
28"
CWS
011
031301
101CS1P
SA-JER-DS011-TRJR-480207
SA-JER-DS011-TRJR-480083
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
11.00
-1.00
80.00
SA-JER-DS011-TRJR-480083
28"
CWS
011
031301
101CS1P
SA-JER-DS011-TRJR-480082
HEADER
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
11.00
-1.00
80.00
80.00
-
H
SA-JER-DS011-TRJR-480275
4"
CWS
011
033017
106CH2S
Reducer
Reducer
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
033017
106CH2S
Reducer
3/4"-CWS-011033018-106CH2SN
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
033017
106CH2S
3/4"-CWS-011033017-106CH2SN
Reducer
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
H
SA-JER-DS011-TRJR-480275
1/2"
CWS
011
033017
106CH2S
Reducer
Reducer
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
-
SA-JER-DS011-TRJR-480275
1/4"
CWS
011
033017
106CH2S
Reducer
SAMPLE CYLINDER
-
-
N
-
SOUR WATER
Liquid
988
9.30
50.00
-
-
54.70
150.00
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
033018
106CH2S
3/4"-CWS-011033018-106CH2SN
Reducer
-
-
N
-
SOUR WATER
Liquid
988
8.20
50.00
-
-
54.70
SA-JER-DS011-TRJR-480275
1/2"
CWS
011
033018
106CH2S
Reducer
Reducer
-
-
N
-
SOUR WATER
Liquid
988
8.20
50.00
-
-
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
033018
106CH2S
Reducer
Reducer
-
-
N
-
SOUR WATER
Liquid
988
8.20
50.00
-
SA-JER-DS011-TRJR-480275
2"
CWS
011
033018
106CH2S
Reducer
2"-CLD-011200308-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
988
8.20
50.00
SA-JER-DS011-TRJR-480275
1/4"
CWS
011
033018
106CH2S
SAMPLE CYLINDER
Reducer
-
-
N
-
SOUR WATER
Liquid
988
8.20
SA-JER-DS011-TRJR-480275
1/2"
CWS
011
033018
106CH2S
Reducer
1/2"-CWS-011033018-106CH2SN
-
-
N
-
SOUR WATER
Liquid
988
SA-JER-DS011-TRJR-480207
4"
CWS
011
035302
101CS1P
4"-CWS-011072312-301FE0W-N
SA-JER-DS011-TRJR-480092
-
-
N
-
SOFT CW
Liquid
SA-JER-DS011-TRJR-480092
4"
CWS
011
035302
101CS1P
SA-JER-DS011-TRJR-480207
011-E-0036
-
-
N
-
SOFT CW
SA-JER-DS011-TRJR-480262
4"
CWS
011
035303
101SD0P
4"-CWS-011035306-101CS1P-N
Reducer
-
-
N
-
SA-JER-DS011-TRJR-480262
2"
CWS
011
035303
101SD0P
Reducer
011-E-0043
-
-
N
SA-JER-DS011-TRJR-480240
3"
CWS
011
035306
101CS1P
3"-CWS-011080302-301FE0W-N
SA-JER-DS011-TRJR-480262
-
-
N
SA-JER-DS011-TRJR-480262
3"
CWS
011
035306
101CS1P
SA-JER-DS011-TRJR-480240
Reducer
-
-
N
SA-JER-DS011-TRJR-380001
16.50
-
80.00
MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. NOTE 10
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC.
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
-
-
-
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
-
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
-
50.00
-
-
54.70
150.00
-
-
-
NFS
YES
A or Q
N
N
N
Y
N
N
-
-
8.20
50.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
A or Q
N
N
N
Y
N
N
-
-
994
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
Liquid
993
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SOFT CW
Liquid
994
5.00
34.50
-
-
9.00
80.00
-
H
13.50
NFS
NO
E
N
N
N
N
N
N
By Vendor
-
-
SOFT CW
Liquid
994
5.00
34.50
-
-
9.00
-
H
13.50
NFS
NO
E
N
N
N
N
N
N
By Vendor
-
-
AUXILIARY CW
Liquid
994
5.00
34.50
-
-
9.00
-1.00
80.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
-
AUXILIARY CW
Liquid
994.4
5.00
34.50
-
-
9.00
-1.00
80.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
80.00
MAX. TEMPERATURE FOR THERMAL EXPANSION: 80ºC. THIS LINE IS ALREADY DRAW IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. THIS LINE IS ALREADY DRAW IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE.
Page 61 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
INSULATION (NOTE 2)
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG) -1.00
STRESS TEMP
TEMP. (ºC) 80.00
80.00
(ºC)
TEST CONDITIONS
MEDIUM (NOTE 5)
PRESS. (BARG)
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6)
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480262
4"
CWS
011
035306
101CS1P
Reducer
4"-CWS-011035303-101SD0P-N
-
-
N
-
AUXILIARY CW
Liquid
994.4
5.00
34.50
-
-
9.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480262
1"
CWS
011
035307
101CS1P
4"-CWS-011035303-101SD0P-N
SA-JER-DS011-TRJR-480091
-
-
N
-
SOFT CW
Liquid
994
5.00
34.50
-
-
9.00
80.00
-
H
13.50
NFS
By Code
A or Q
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480091
1"
CWS
011
035307
101CS1P
SA-JER-DS011-TRJR-480262
011-K-0001
-
-
N
-
SOFT CW
Liquid
994
5.00
34.50
-
-
9.00
80.00
-
H
13.50
NFS
By Code
A or Q
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480275
1"
CWS
011
036004
101CH2S
1"-CWS-011036004-101CH2S-N
Reducer
-
-
N
-
SOUR WATER
Liquid/Gas Mixture
56
0.90
41.00
-
-
4.00
-1.00
250.00
100.00
-
H
6.28
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480275
1/2"
CWS
011
036004
101CH2S
Reducer
Reducer
-
-
N
-
SOUR WATER
Liquid/Gas Mixture
56
0.90
41.00
-
-
4.00
-1.00
250.00
100.00
-
H
6.28
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
036004
101CH2S
Reducer
Reducer
-
-
N
-
SOUR WATER
Liquid/Gas Mixture
56
0.90
41.00
-
-
4.00
-1.00
250.00
100.00
-
H
6.28
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480275
2"
CWS
011
036004
101CH2S
Reducer
2"-CLD-011200312-101CH2S-N
-
-
N
-
SOUR WATER
Liquid/Gas Mixture
56
0.90
41.00
-
-
4.00
-1.00
250.00
100.00
-
H
6.28
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480275
1/4"
CWS
011
036004
101CH2S
SAMPLE CYLINDER
Reducer
-
-
N
-
SOUR WATER
Liquid/Gas Mixture
56
0.90
41.00
-
-
4.00
-1.00
250.00
100.00
-
-
-
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTES 6,7
-
-
N
-
SOUR WATER
Liquid/Gas Mixture
56
0.90
41.00
-
-
4.00
-1.00
250.00
100.00
-
H
6.28
NFS
YES
A or Q
N
N
N
Y
N
N
-
-
-
N
-
SOUR WATER
Liquid
694
2.10
41.00
-
-
4.00
105.00
-
H
6.00
D
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480275
1/2"
CWS
011
036004
101CH2S
Reducer
1/2"-CWS-011036004-101CH2SN
SA-JER-DS011-TRJR-480275
4"
CWS
011
036005
101CH4S
Reducer
Reducer
NOTES 6,7 THIS LINE IS ALREADY DRAW IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. NOTE 6. THIS LINE IS ALREADY DRAW IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. NOTE 6.
SA-JER-DS011-TRJR-480275
1"
CWS
011
036005
101CH4S
Reducer
1"-CWS-011036004-101CH2S-N
-
-
N
-
SOUR WATER
Liquid
694
2.10
41.00
-
-
4.00
105.00
-
H
6.00
D
YES
A or Q
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
036005
101CH4S
1"-CWS-011036005-101CH4S-N
Reducer
-
-
N
-
SOUR WATER
Liquid
694
2.10
41.00
-
-
4.00
105.00
-
-
-
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/2"
CWS
011
036005
101CH4S
Reducer
Reducer
-
-
N
-
SOUR WATER
Liquid
694
2.10
41.00
-
-
4.00
105.00
-
-
-
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/4"
CWS
011
036005
101CH4S
Reducer
SAMPLE CYLINDER
-
-
N
-
SOUR WATER
Liquid
694
2.10
41.00
-
-
4.00
105.00
-
-
-
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480207
4"
CWS
011
037301
101CS1P
4"-CWS-011072306-301FE0W-N
SA-JER-DS011-TRJR-480098
-
-
N
-
SOFT CW
Liquid
994
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480098
4"
CWS
011
037301
101CS1P
SA-JER-DS011-TRJR-480207
4"-CWS-011037301-101CS1P-N
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480098
4"
CWS
011
037301
101CS1P
4"-CWS-011037301-101CS1P-N
011-E-0029
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
16.20
80.00
-
H
24.30
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
12"
CWS
011
042301
101CS1P
12"-CWS-011072303-301FE0WN
SA-JER-DS011-TRJR-480109
-
-
N
-
SOFT CW
Liquid
994
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480109
12"
CWS
011
042301
101CS1P
SA-JER-DS011-TRJR-480207
12"-CWS-011042301-101CS1P-N
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480109
12"
CWS
011
042301
101CS1P 12"-CWS-011042301-101CS1P-N
011-E-0033
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
12.40
80.00
-
H
18.60
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
044010
106CH2S
3"-NPH-091034003-103CH2S-N
Reducer
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480275
4"
CWS
011
044010
106CH2S
Reducer
Reducer
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
044010
106CH2S
Reducer
3/4"-CWS-011044011-106CH2SP
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
044010
106CH2S
3/4"-CWS-011044010-106CH2SP
Reducer
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/2"
CWS
011
044010
106CH2S
Reducer
Reducer
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/4"
CWS
011
044010
106CH2S
Reducer
SAMPLE CYLINDER
-
-
P
25
SOUR WATER
Liquid
980
9.20
62.00
-
-
54.70
110.00
-
-
-
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
044011
106CH2S
6"-SRW-011044002-106CH2S-P
-
-
P
25
SOUR WATER
Liquid
980
7.90
62.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
044011
106CH2S
SA-JER-DS011-TRJR-480275
1/2"
CWS
011
044011
106CH2S
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
044011
3/4"-CWS-011044010-106CH2SP 3/4"-CWS-011044011-106CH2SP
THIS LINE IS ALREADY DRAW IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. NOTE 6. THIS LINE IS ALREADY DRAW IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. NOTE 6. THIS LINE IS ALREADY DRAW IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. NOTE 6.
Reducer
-
-
P
25
SOUR WATER
Liquid
980
7.90
62.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6.
Reducer
Reducer
-
-
P
25
SOUR WATER
Liquid
980
7.90
62.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6.
106CH2S
Reducer
Reducer
-
-
P
25
SOUR WATER
Liquid
980
7.90
62.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6.
Plug
-
-
P
25
SOUR WATER
Liquid
980
7.90
62.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6.
2"-CLD-011200303-101CH2S-N
-
-
P
25
SOUR WATER
Liquid
980
7.90
62.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
044011
106CH2S
3/4"-CWS-011044011-106CH2SP
SA-JER-DS011-TRJR-480275
2"
CWS
011
044011
106CH2S
Reducer
SA-JER-DS011-TRJR-480275
1/4"
CWS
011
044011
106CH2S
SAMPLE CYLINDER
Reducer
-
-
P
25
SOUR WATER
Liquid
980
7.90
62.00
-
-
54.70
150.00
-
-
-
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6.
-
-
P
25
SOUR WATER
Liquid
980
7.90
62.00
-
-
54.70
150.00
-
H
82.05
NFS
YES
M
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/2"
CWS
011
044011
106CH2S
Reducer
1/2"-CWS-011044011-106CH2SP
SA-JER-DS011-TRJR-480207
40"
CWS
011
072301
301FE0W
IP-6042-S
Cap
-
-
N
-
SOFT CW
Liquid
994
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
18"
CWS
011
072302
301FE0W
40"-CWS-011072301-301FE0WN
SA-JER-DS011-TRJR-480136
-
-
N
-
SOFT CW
Liquid
990
6.00
36.50
-
-
23.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480136
18"
CWS
011
072302
301FE0W
SA-JER-DS011-TRJR-480207
Reducer
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
23.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480136
14"
CWS
011
072302
301FE0W
Reducer
14"-CWS-011098001-101CS1P-N
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
23.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
12"
CWS
011
072303
301FE0W
12"-CWS-011042301-101CS1P-N
-
-
N
-
SOFT CW
Liquid
994
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
6"
CWS
011
072304
301FE0W
6"-CWS-011025302-101CS1P-N
-
-
N
-
SOFT CW
Liquid
994
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
6"
CWS
011
072305
301FE0W
6"-CWS-011025303-101CS1P-N
-
-
N
-
SOFT CW
Liquid
994
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
4"
CWS
011
072306
301FE0W
4"-CWS-011037301-101CS1P-N
-
-
N
-
SOFT CW
Liquid
994
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
10"
CWS
011
072307
301FE0W
10"-CWS-011025301-101CS1P-N
-
-
N
-
SOFT CW
Liquid
994
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
12"
CWS
011
072308
301FE0W
12"-CWS-011020301-101CS1P-N
-
-
N
-
SOFT CW
Liquid
994
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
28"
CWS
011
072309
301FE0W
28"-CWS-011031301-101CS1P-N
-
-
N
-
SOFT CW
Liquid
994
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
4"
CWS
011
072312
301FE0W
4"-CWS-011035302-101CS1P-N
-
-
N
-
SOFT CW
Liquid
994
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
6"
CWS
011
072313
301FE0W
6"-CWS-011072313-101CS1P-N
-
-
N
-
SOFT CW
Liquid
994
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
6"
CWS
011
072313
101CS1P
6"-CWS-011072313-301FE0W-N
FUTURE CONNECTION
-
-
N
-
SOFT CW
Liquid
994
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
6"
CWS
011
072314
301FE0W
40"-CWS-011072301-301FE0WN
6"-CWS-011072314-101CS1P-N
-
-
N
-
SOFT CW
Liquid
994
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480207
6"
CWS
011
072314
101CS1P
6"-CWS-011072314-301FE0W-N
FUTURE CONNECTION
-
-
N
-
SOFT CW
Liquid
994
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
8"
CWS
011
080302
301FE0W
IP-6040-S
SA-JER-DS011-TRJR-480239
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
8"
CWS
011
080302
301FE0W
SA-JER-DS011-TRJR-480237
8"-CWS-011171395-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
6"
CWS
011
080302
301FE0W
8"-CWS-011080302-301FE0W-N
SA-JER-DS011-TRJR-480240
-
-
N
-
AUXILIARY CW
Liquid
990
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
6"
CWS
011
080302
301FE0W
SA-JER-DS011-TRJR-480239
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
3"
CWS
011
080302
301FE0W
Reducer
3"-CWS-011035306-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
14"-CWS-011072302-301FE0W14"-CWS-011098002-103CS1P-N N
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
23.00
80.00
-
H
34.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
11.00
80.00
-
H
16.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
-
-
N
-
SOFT CW
Liquid
993
6.00
36.50
-
-
23.00
80.00
-
H
34.50
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
40"-CWS-011072301-301FE0WN 40"-CWS-011072301-301FE0WN 40"-CWS-011072301-301FE0WN 40"-CWS-011072301-301FE0WN 40"-CWS-011072301-301FE0WN 40"-CWS-011072301-301FE0WN 40"-CWS-011072301-301FE0WN 40"-CWS-011072301-301FE0WN 40"-CWS-011072301-301FE0WN
SA-JER-DS011-TRJR-480136
14"
CWS
011
098001
101CS1P
SA-JER-DS011-TRJR-480136
14"
CWS
011
098002
103CS1P 14"-CWS-011098001-101CS1P-N
011-E-0037-B
14"-CWS-011072302-301FE0W14"-CWS-011098004-103CS1P-N N
SA-JER-DS011-TRJR-480136
14"
CWS
011
098003
101CS1P
SA-JER-DS011-TRJR-480136
14"
CWS
011
098004
103CS1P 14"-CWS-011098003-101CS1P-N
011-E-0037-D
if insulated M or Q SA-JER-DS011-TRJR-480136
-
CWS
011
098601
103CS1P
011-E-0037-A/B/C/D
TRIM
-
-
N
-
-
-
-
6.00
36.50
-
-
23.00
80.00
-
Visual Test
0.00
NFS
By Code
if NOT insulated A or Q
SA-JER-DS011-TRJR-480237
2"
CWS
011
171301
101CS1P
2"-CWS-011171348-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
3/4"
CWS
011
171301
101CS1P
Reducer
SA-JER-DS011-TRJR-480249
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480249
3/4"
CWS
011
171301
101CS1P
SA-JER-DS011-TRJR-480237
011-G-0026-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
2"
CWS
011
171302
101CS1P
2"-CWS-011171347-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
3/4"
CWS
011
171302
101CS1P
Reducer
SA-JER-DS011-TRJR-480249
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480249
3/4"
CWS
011
171302
101CS1P
SA-JER-DS011-TRJR-480237
011-G-0026-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
2"
CWS
011
171305
101CS1P
2"-CWS-011171352-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
1"
CWS
011
171305
101CS1P
Reducer
SA-JER-DS011-TRJR-480245
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
1"
CWS
011
171305
101CS1P
SA-JER-DS011-TRJR-480237
011-G-0002-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
2"
CWS
011
171306
101CS1P
2"-CWS-011171351-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
1"
CWS
011
171306
101CS1P
Reducer
SA-JER-DS011-TRJR-480245
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
1"
CWS
011
171306
101CS1P
SA-JER-DS011-TRJR-480237
011-G-0002-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWS
011
171307
101CS1P
2"-CWS-011171353-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
3/4"
CWS
011
171307
101CS1P
Reducer
SA-JER-DS011-TRJR-480250
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
3/4"
CWS
011
171307
101CS1P
SA-JER-DS011-TRJR-480238
011-G-0028-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWS
011
171309
101CS1P
2"-CWS-011171354-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
3/4"
CWS
011
171309
101CS1P
Reducer
SA-JER-DS011-TRJR-480250
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
Page 62 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9) CWS
UNIT
NUMBER
LINE CLASS
011
171309
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
011-G-0028-A
-
FLUID
PHASE
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
101CS1P
SA-JER-DS011-TRJR-480238
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWS
011
171310
101CS1P
2"-CWS-011171355-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
3/4"
CWS
011
171310
101CS1P
Reducer
SA-JER-DS011-TRJR-480250
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
3/4"
CWS
011
171310
101CS1P
SA-JER-DS011-TRJR-480238
011-G-0024-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWS
011
171313
101CS1P
2"-CWS-011171360-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
3/4"
CWS
011
171313
101CS1P
Reducer
SA-JER-DS011-TRJR-480249
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480249
3/4"
CWS
011
171313
101CS1P
SA-JER-DS011-TRJR-480238
011-G-0025-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
2"-CWS-011171362-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
-
N
-
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
3/4"
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
DOC. No.
SA-JER-DS011-TRJR-480238
2"
CWS
011
171315
101CS1P
SA-JER-DS011-TRJR-480238
3/4"
CWS
011
171315
101CS1P
Reducer
SA-JER-DS011-TRJR-480251
-
AUXILIARY CW
Liquid
SA-JER-DS011-TRJR-480251
3/4"
CWS
011
171315
101CS1P
SA-JER-DS011-TRJR-480238
011-G-0003-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWS
011
171316
101CS1P
2"-CWS-011171361-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
3/4"
CWS
011
171316
101CS1P
Reducer
SA-JER-DS011-TRJR-480251
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480251
3/4"
CWS
011
171316
101CS1P
SA-JER-DS011-TRJR-480238
011-G-0003-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWS
011
171317
101CS1P
2"-CWS-011171364-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
1"
CWS
011
171317
101CS1P
Reducer
SA-JER-DS011-TRJR-480245
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
1"
CWS
011
171317
101CS1P
SA-JER-DS011-TRJR-480238
011-G-0004-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWS
011
171318
101CS1P
2"-CWS-011171363-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
1"
CWS
011
171318
101CS1P
Reducer
SA-JER-DS011-TRJR-480245
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
1"
CWS
011
171318
101CS1P
SA-JER-DS011-TRJR-480238
011-G-0004-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171319
101CS1P
2"-CWS-011171365-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1-1/2"
CWS
011
171319
101CS1P
Reducer
SA-JER-DS011-TRJR-480252
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480252
1-1/2"
CWS
011
171319
101CS1P
SA-JER-DS011-TRJR-480239
011-G-0008-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171320
101CS1P
2"-CWS-011171366-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1-1/2"
CWS
011
171320
101CS1P
Reducer
SA-JER-DS011-TRJR-480252
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480252
1-1/2"
CWS
011
171320
101CS1P
SA-JER-DS011-TRJR-480239
011-G-0008-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171321
101CS1P
2"-CWS-011171367-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1"
CWS
011
171321
101CS1P
Reducer
SA-JER-DS011-TRJR-480253
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480253
1"
CWS
011
171321
101CS1P
SA-JER-DS011-TRJR-480239
011-G-0005-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171322
101CS1P
2"-CWS-011171368-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480253
1"
CWS
011
171322
101CS1P
SA-JER-DS011-TRJR-480239
011-G-0005-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171323
101CS1P
2"-CWS-011171369-301FE0W-N
SA-JER-DS011-TRJR-480246
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480246
2"
CWS
011
171323
101CS1P
SA-JER-DS011-TRJR-480239
011-G-0010-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171324
101CS1P
2"-CWS-011171370-301FE0W-N
SA-JER-DS011-TRJR-480246
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480246
2"
CWS
011
171324
101CS1P
SA-JER-DS011-TRJR-480239
011-G-0010-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171325
101CS1P
2"-CWS-011171372-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1"
CWS
011
171325
101CS1P
Reducer
SA-JER-DS011-TRJR-480245
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
1"
CWS
011
171325
101CS1P
SA-JER-DS011-TRJR-480239
011-G-0007-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171326
101CS1P
2"-CWS-011171371-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1"
CWS
011
171326
101CS1P
Reducer
SA-JER-DS011-TRJR-480245
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
1"
CWS
011
171326
101CS1P
SA-JER-DS011-TRJR-480239
011-G-0007-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171327
101CS1P
2"-CWS-011171373-301FE0W-N
SA-JER-DS011-TRJR-480263
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480263
2"
CWS
011
171327
101CS1P
SA-JER-DS011-TRJR-480239
011-G-0012-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171328
101CS1P
2"-CWS-011171374-301FE0W-N
SA-JER-DS011-TRJR-480263
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480263
2"
CWS
011
171328
101CS1P
SA-JER-DS011-TRJR-480239
011-G-0012-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171329
101CS1P
2"-CWS-011171375-301FE0W-N
SA-JER-DS011-TRJR-480247
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480247
2"
CWS
011
171329
101CS1P
SA-JER-DS011-TRJR-480239
011-G-0014-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171330
101CS1P
2"-CWS-011171376-301FE0W-N
SA-JER-DS011-TRJR-480247
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480247
2"
CWS
011
171330
101CS1P
SA-JER-DS011-TRJR-480239
011-G-0014-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171331
101CS1P
2"-CWS-011171378-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1-1/2"
CWS
011
171331
101CS1P
Reducer
SA-JER-DS011-TRJR-480250
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
1-1/2"
CWS
011
171331
101CS1P
SA-JER-DS011-TRJR-480239
011-G-0013-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171332
101CS1P
2"-CWS-011171377-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1-1/2"
CWS
011
171332
101CS1P
Reducer
SA-JER-DS011-TRJR-480250
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
1-1/2"
CWS
011
171332
101CS1P
SA-JER-DS011-TRJR-480239
011-G-0013-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171333
101CS1P
2"-CWS-011171379-301FE0W-N
SA-JER-DS011-TRJR-480247
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480247
2"
CWS
011
171333
101CS1P
SA-JER-DS011-TRJR-480240
011-G-0018-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171334
101CS1P
2"-CWS-011171380-301FE0W-N
SA-JER-DS011-TRJR-480247
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480247
2"
CWS
011
171334
101CS1P
SA-JER-DS011-TRJR-480240
011-G-0018-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171335
101CS1P
2"-CWS-011171381-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
1"
CWS
011
171335
101CS1P
Reducer
SA-JER-DS011-TRJR-480245
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
1"
CWS
011
171335
101CS1P
SA-JER-DS011-TRJR-480240
011-G-0017-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171336
101CS1P
2"-CWS-011171382-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
1"
CWS
011
171336
101CS1P
Reducer
SA-JER-DS011-TRJR-480245
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
1"
CWS
011
171336
101CS1P
SA-JER-DS011-TRJR-480240
011-G-0017-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171337
101CS1P
2"-CWS-011171383-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
1"
CWS
011
171337
101CS1P
Reducer
SA-JER-DS011-TRJR-480247
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480247
1"
CWS
011
171337
101CS1P
SA-JER-DS011-TRJR-480240
011-G-0016-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171338
101CS1P
2"-CWS-011171384-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
1"
CWS
011
171338
101CS1P
Reducer
SA-JER-DS011-TRJR-480247
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480247
1"
CWS
011
171338
101CS1P
SA-JER-DS011-TRJR-480240
011-G-0016-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171339
101CS1P
2"-CWS-011171385-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
1-1/2"
CWS
011
171339
101CS1P
Reducer
SA-JER-DS011-TRJR-480253
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480253
1-1/2"
CWS
011
171339
101CS1P
SA-JER-DS011-TRJR-480240
011-G-0015-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171340
101CS1P
2"-CWS-011171386-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
1-1/2"
CWS
011
171340
101CS1P
Reducer
SA-JER-DS011-TRJR-480253
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480253
1-1/2"
CWS
011
171340
101CS1P
SA-JER-DS011-TRJR-480240
011-G-0015-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171341
101CS1P
2"-CWS-011171387-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
3/4"
CWS
011
171341
101CS1P
Reducer
SA-JER-DS011-TRJR-480248
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480248
3/4"
CWS
011
171341
101CS1P
SA-JER-DS011-TRJR-480240
011-G-0020-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171342
101CS1P
2"-CWS-011171388-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
3/4"
CWS
011
171342
101CS1P
Reducer
SA-JER-DS011-TRJR-480248
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480248
3/4"
CWS
011
171342
101CS1P
SA-JER-DS011-TRJR-480240
011-G-0020-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171343
101CS1P
2"-CWS-011171390-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1-1/2"
CWS
011
171343
101CS1P
Reducer
SA-JER-DS011-TRJR-480252
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480252
1-1/2"
CWS
011
171343
101CS1P
SA-JER-DS011-TRJR-480239
011-G-0009-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171344
101CS1P
2"-CWS-011171389-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1-1/2"
CWS
011
171344
101CS1P
Reducer
SA-JER-DS011-TRJR-480252
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480252
1-1/2"
CWS
011
171344
101CS1P
SA-JER-DS011-TRJR-480239
011-G-0009-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171345
101CS1P
2"-CWS-011171392-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1-1/2"
CWS
011
171345
101CS1P
Reducer
SA-JER-DS011-TRJR-480250
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
1-1/2"
CWS
011
171345
101CS1P
SA-JER-DS011-TRJR-480239
011-G-0011-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
Page 63 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480239
2"
CWS
011
171346
101CS1P
2"-CWS-011171391-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
1-1/2"
CWS
011
171346
101CS1P
Reducer
SA-JER-DS011-TRJR-480250
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
1-1/2"
CWS
011
171346
101CS1P
SA-JER-DS011-TRJR-480239
011-G-0011-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
2"
CWS
011
171347
301FE0W
2"-CWS-011171348-301FE0W-N
2"-CWS-011171302-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
2"
CWS
011
171348
301FE0W
8"-CWS-011080302-301FE0W-N
2"-CWS-011171301-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
2"
CWS
011
171351
301FE0W
3"-CWS-011171352-301FE0W-N
2"-CWS-011171306-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
3"
CWS
011
171352
301FE0W
8"-CWS-011080302-301FE0W-N
HEADER
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
2"
CWS
011
171352
301FE0W
3"-CWS-011171352-301FE0W-N
2"-CWS-011171305-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWS
011
171353
301FE0W
3"-CWS-011171393-301FE0W-N
2"-CWS-011171307-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWS
011
171354
301FE0W
3"-CWS-011171393-301FE0W-N
2"-CWS-011171309-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWS
011
171355
301FE0W
3"-CWS-011171393-301FE0W-N
2"-CWS-011171310-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWS
011
171356
301FE0W
3"-CWS-011171393-301FE0W-N
2"-CWS-011171399-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWS
011
171360
301FE0W
3"-CWS-011171393-301FE0W-N
2"-CWS-011171313-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWS
011
171361
301FE0W
6"-CWS-011171393-301FE0W-N
2"-CWS-011171316-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWS
011
171362
301FE0W
6"-CWS-011171393-301FE0W-N
2"-CWS-011171315-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWS
011
171363
301FE0W
6"-CWS-011171393-301FE0W-N
2"-CWS-011171318-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWS
011
171364
301FE0W
6"-CWS-011171393-301FE0W-N
2"-CWS-011171317-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171365
301FE0W
6"-CWS-011171395-301FE0W-N
2"-CWS-011171319-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171366
301FE0W
6"-CWS-011171395-301FE0W-N
2"-CWS-011171320-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171367
301FE0W
6"-CWS-011171395-301FE0W-N
2"-CWS-011171321-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171368
301FE0W
6"-CWS-011171395-301FE0W-N
2"-CWS-011171322-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171369
301FE0W
6"-CWS-011171395-301FE0W-N
2"-CWS-011171323-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171370
301FE0W
6"-CWS-011171395-301FE0W-N
2"-CWS-011171324-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171371
301FE0W
8"-CWS-011080302-301FE0W-N
2"-CWS-011171326-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171372
301FE0W
8"-CWS-011080302-301FE0W-N
2"-CWS-011171325-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171373
301FE0W
6"-CWS-011171395-301FE0W-N
2"-CWS-011171327-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171374
301FE0W
6"-CWS-011171395-301FE0W-N
2"-CWS-011171328-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171375
301FE0W
6"-CWS-011171395-301FE0W-N
2"-CWS-011171329-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171376
301FE0W
6"-CWS-011171395-301FE0W-N
2"-CWS-011171330-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171377
301FE0W
8"-CWS-011080302-301FE0W-N
2"-CWS-011171332-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171378
301FE0W
8"-CWS-011080302-301FE0W-N
2"-CWS-011171331-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171379
301FE0W
6"-CWS-011171395-301FE0W-N
2"-CWS-011171333-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171380
301FE0W
6"-CWS-011171395-301FE0W-N
2"-CWS-011171334-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171381
301FE0W
6"-CWS-011171395-301FE0W-N
2"-CWS-011171335-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171382
301FE0W
6"-CWS-011171395-301FE0W-N
2"-CWS-011171336-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171383
301FE0W
2"-CWS-011171384-301FE0W-N
2"-CWS-011171337-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171384
301FE0W
6"-CWS-011171395-301FE0W-N
2"-CWS-011171338-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171385
301FE0W
6"-CWS-011171395-301FE0W-N
2"-CWS-011171339-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171386
301FE0W
6"-CWS-011171395-301FE0W-N
2"-CWS-011171340-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171387
301FE0W
6"-CWS-011080302-301FE0W-N
2"-CWS-011171341-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171388
301FE0W
6"-CWS-011080302-301FE0W-N
2"-CWS-011171342-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171389
301FE0W
8"-CWS-011080302-301FE0W-N
2"-CWS-011171344-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171390
301FE0W
8"-CWS-011080302-301FE0W-N
2"-CWS-011171343-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171391
301FE0W
6"-CWS-011171395-301FE0W-N
2"-CWS-011171346-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
2"
CWS
011
171392
301FE0W
6"-CWS-011171395-301FE0W-N
2"-CWS-011171345-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
6"
CWS
011
171393
301FE0W
HEADER
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
3"
CWS
011
171393
301FE0W
Reducer
HEADER
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
3"
CWS
011
171393
301FE0W
3"-CWS-011171393-301FE0W-N
HEADER
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
6"
CWS
011
171395
301FE0W
SA-JER-DS011-TRJR-480239
6"-CWS-011171393-301FE0W-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
6"
CWS
011
171395
301FE0W
Reducer
SA-JER-DS011-TRJR-480240
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
8"
CWS
011
171395
301FE0W
Reducer
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480239
6"
CWS
011
171395
301FE0W
Reducer
SA-JER-DS011-TRJR-480238
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
6"
CWS
011
171395
301FE0W
SA-JER-DS011-TRJR-480239
HEADER
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171397
301FE0W
6"-CWS-011171395-301FE0W-N
2"-CWS-011171398-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
2"
CWS
011
171398
101CS1P
2"-CWS-011171397-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
3/4"
CWS
011
171398
101CS1P
Reducer
SA-JER-DS011-TRJR-480251
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480251
3/4"
CWS
011
171398
101CS1P
SA-JER-DS011-TRJR-480240
011-G-0027
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
2"-CWS-011171356-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
-
N
-
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWS
011
171399
101CS1P
SA-JER-DS011-TRJR-480238
3/4"
CWS
011
171399
101CS1P
Reducer
SA-JER-DS011-TRJR-480250
-
AUXILIARY CW
Liquid
SA-JER-DS011-TRJR-480250
3/4"
CWS
011
171399
101CS1P
SA-JER-DS011-TRJR-480238
011-G-0024-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
200001
101CH2S
SAMPLE COOLER
Reducer
-
-
N
-
SOUR WATER
Liquid
970
3.80
60.00
-
-
6.50
140.00
-
H
9.75
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
4"
CWS
011
200001
101CH2S
Reducer
Reducer
-
-
N
-
SOUR WATER
Liquid
970
3.80
60.00
-
-
6.50
140.00
-
H
9.75
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
200001
101CH2S
Reducer
3/4"-CWS-011012003-101CH2SP
-
-
N
-
SOUR WATER
Liquid
970
3.80
60.00
-
-
6.50
140.00
-
H
9.75
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
200001
101CH2S
3/4"-CWS-011200001-101CH2SN
Reducer
-
-
N
-
SOUR WATER
Liquid
970
3.80
60.00
-
-
6.50
140.00
-
H
9.75
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/2"
CWS
011
200001
101CH2S
Reducer
Reducer
-
-
N
-
SOUR WATER
Liquid
970
3.80
60.00
-
-
6.50
140.00
-
H
9.75
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/4"
CWS
011
200001
101CH2S
Reducer
SAMPLE CYLINDER
-
-
N
-
SOUR WATER
Liquid
970
3.80
60.00
-
-
6.50
140.00
-
-
-
D
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
200002
101CH2S
SAMPLE COOLER
Reducer
-
-
N
-
SOUR WATER
Liquid
981
1.02
60.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
4"
CWS
011
200002
101CH2S
Reducer
Reducer
-
-
N
-
SOUR WATER
Liquid
981
1.02
60.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
200002
101CH2S
Reducer
3/4"-CWS-011019008-101CH2SP
-
-
N
-
SOUR WATER
Liquid
981
1.02
60.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
CWS
011
200002
101CH2S
3/4"-CWS-011200002-101CH2SN
Reducer
-
-
N
-
SOUR WATER
Liquid
981
1.02
60.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/2"
CWS
011
200002
101CH2S
Reducer
Reducer
-
-
N
-
SOUR WATER
Liquid
981
1.02
60.00
-
-
5.00
200.00
-
H
7.50
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/4"
CWS
011
200002
101CH2S
Reducer
SAMPLE CYLINDER
-
-
N
-
SOUR WATER
Liquid
981
1.02
60.00
-
-
5.00
200.00
-
-
-
NFS
YES
A or Q
N
N
N
Y
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480238
2"
CWS
011
230302
101CS1P
2"-CWS-011230305-301FE0W-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
1"
CWS
011
230302
101CS1P
Reducer
SA-JER-DS011-TRJR-480290
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480290
1"
CWS
011
230302
101CS1P
SA-JER-DS011-TRJR-480238
011-AS-0002
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
2"
CWS
011
230304
301FE0W
8"-CWS-011080302-301FE0W-N
HEADER
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
2"
CWS
011
230305
301FE0W
3"-CWS-011171393-301FE0W-N
2"-CWS-011230302-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
1"
CWS
011
405301
101CS1P
3"-CWS-011525301-101CS1P-N
SA-JER-DS011-TRJR-480267
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1"
CWS
011
405301
101CS1P
SA-JER-DS011-TRJR-480240
1"-CWS-011405302-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1"
CWS
011
405302
101CS1P
1"-CWS-011405301-101CS1P-N
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480267
4"
CWS
011
405302
101CS1P
Reducer
Reducer
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480267
1"
CWS
011
405302
101CS1P
Reducer
011-E-0048-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480267
1"
CWS
011
405302
101CS1P
1"-CWS-011405302-101CS1P-N
011-E-0048-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480237
2"
CWS
011
446301
101CS1P
2"-CWS-011446303-301FE0W-N
HEADER
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
1-1/2"
CWS
011
446301
101CS1P
2"-CWS-011446301-101CS1P-N
SA-JER-DS011-TRJR-480254
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480254
1-1/2"
CWS
011
446301
101CS1P
SA-JER-DS011-TRJR-480237
N5
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480254
1-1/2"
CWS
011
446302
101CS1P
N5
011-E-0044-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
011-E-0044-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
1-1/2"
CWS
011
446302
101CS1P
1-1/2"-CWS-011446302101CS1P-N
SA-JER-DS011-TRJR-480237
2"
CWS
011
446303
301FE0W
8"-CWS-011080302-301FE0W-N
2"-CWS-011446301-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
2"
CWS
011
450301
101CS1P
2"-CWS-011450302-301FE0W-N
HEADER
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
Page 64 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
INSULATION (NOTE 2)
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
(NOTE 3)
DOC. No.
DENSITY (kg/m3)
(NOTE 4)
OPERATING CONDITIONS PRESS. (BARG)
TEMP. (ºC)
DESIGN CONDITIONS
ALTERNATE CONDITIONS PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
(ºC)
TEST CONDITIONS
MEDIUM (NOTE 5)
PRESS. (BARG)
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6)
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480237
1-1/2"
CWS
011
450301
101CS1P
2"-CWS-011450301-101CS1P-N
SA-JER-DS011-TRJR-480256
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480256
1-1/2"
CWS
011
450301
101CS1P
SA-JER-DS011-TRJR-480237
1-1/2"-CWS-011450303-101CS1PN
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480237
2"
CWS
011
450302
301FE0W
3"-CWS-011171352-301FE0W-N
2"-CWS-011450301-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
011-E-0045-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
011-E-0045-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
1-1/2"-CWS-011450301101CS1P-N 1-1/2"-CWS-011450303101CS1P-N
SA-JER-DS011-TRJR-480256
1-1/2"
CWS
011
450303
101CS1P
SA-JER-DS011-TRJR-480256
1-1/2"
CWS
011
450303
101CS1P
SA-JER-DS011-TRJR-480238
3"
CWS
011
460301
101CS1P
3"-CWS-011460302-301FE0W-N
HEADER
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480258
1-1/2"
CWS
011
460301
101CS1P
SA-JER-DS011-TRJR-480238
N5
-
-
N
-
AUXILIARY COOLING WATER
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480238
3"
CWS
011
460302
301FE0W
6"-CWS-011171393-301FE0W-N
3"-CWS-011460301-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480258
1-1/2"
CWS
011
460303
101CS1P
N5
011-E-0046-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
1-1/2"
CWS
011
460303
101CS1P
1-1/2"-CWS-011460303101CS1P-N
011-E-0046-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480240
3"
CWS
011
525301
101CS1P
3"-CWS-011525304-301FE0W-N
HEADER
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480240
1-1/2"
CWS
011
525301
101CS1P
3"-CWS-011525301-101CS1P-N
SA-JER-DS011-TRJR-480260
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480260
1-1/2"
CWS
011
525301
101CS1P
SA-JER-DS011-TRJR-480240
N5
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480260
1-1/2"
CWS
011
525303
101CS1P
N5
011-E-0047-A
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480260
1-1/2"
CWS
011
525303
101CS1P
1-1/2"-CWS-011525303101CS1P-N
011-E-0047-B
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480240
3"
CWS
011
525304
301FE0W
6"-CWS-011171395-301FE0W-N
3"-CWS-011525301-101CS1P-N
-
-
N
-
AUXILIARY CW
Liquid
994
5.00
35.00
-
-
9.00
80.00
-
H
13.50
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480006
12"
DIE
011
003001
103CS1P
011-E-0005
Reducer
-
-
P
25
LVGO
Liquid
810.9
13.17
126.50
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
10"
DIE
011
003001
103CS1P
Reducer
SA-JER-DS011-TRJR-480097
-
-
P
25
LVGO
Liquid
810.9
13.17
126.50
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
DIE
011
003001
103CS1P
10"-DIE-011003001-103CS1P-P
011-TT-0018
-
-
P
25
LVGO
Liquid
810.9
13.17
126.50
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
DIE
011
003001
103CS1P
10"-DIE-011003001-103CS1P-P
Blind flange
-
-
P
25
LVGO
Liquid
810.9
13.17
126.50
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480097
10"
DIE
011
003001
103CS1P
SA-JER-DS011-TRJR-480006
Reducer
-
-
P
25
LVGO
Liquid
810.9
13.17
126.50
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480097
10"
DIE
011
003001
103CS1P
10"-DIE-011003001-103CS1P-P
Reducer
-
-
P
25
LVGO
Liquid
810.9
13.17
126.50
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480097
8"
DIE
011
003001
103CS1P
Reducer
HEADER
-
-
P
25
LVGO
Liquid
810.9
13.17
126.50
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480097
8"
DIE
011
003001
103CS1P
Reducer
HEADER
-
-
P
25
LVGO
Liquid
810.9
13.17
126.50
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480097
6"
DIE
011
003001
103CS1P
8"-DIE-011003001-103CS1P-P
011-A-0005-A/B
-
-
P
25
LVGO
Liquid
810.9
13.17
126.50
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480097
6"
DIE
011
003001
103CS1P
8"-DIE-011003001-103CS1P-P
011-A-0005-C/D
-
-
P
25
LVGO
Liquid
810.9
13.17
126.50
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480097
6"
DIE
011
003001
103CS1P
8"-DIE-011003001-103CS1P-P
011-A-0005-G/H
-
-
P
25
LVGO
Liquid
810.9
13.17
126.50
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480097
6"
DIE
011
003001
103CS1P
8"-DIE-011003001-103CS1P-P
011-A-0005-C/D
-
-
P
25
LVGO
Liquid
810.9
13.17
126.50
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480097
6"
DIE
011
003001
103CS1P
8"-DIE-011003001-103CS1P-P
011-A-0005-E/F
-
-
P
25
LVGO
Liquid
810.9
13.17
126.50
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480097
6"
DIE
011
003001
103CS1P
8"-DIE-011003001-103CS1P-P
011-A-0005-A/B
-
-
P
25
LVGO
Liquid
810.9
13.17
126.50
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480097
6"
DIE
011
003001
103CS1P
8"-DIE-011003001-103CS1P-P
011-A-0005-G/H
-
-
P
25
LVGO
Liquid
810.9
13.17
126.50
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480097
6"
DIE
011
003001
103CS1P
8"-DIE-011003001-103CS1P-P
011-A-0005-E/F
-
-
P
25
LVGO
Liquid
810.9
13.17
126.50
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
DIE
011
003002
103CS1P
UC
2"-DIE-011037003-103CS1P-H
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
3/4"
DIE
011
003002
103CS1P
2"-DIE-011003002-103CS1P-P
Blind flange
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
DIE
011
003003
103CS1P
10"-DIE-011003001-103CS1P-P
2"-CLD-011003312-101CH2S-P
-
-
P
25
LVGO
Liquid
810.9
13.17
126.50
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
DIE
011
003003
103CS1P
2"-DIE-011003003-103CS1P-P
Blind flange
-
-
P
25
LVGO
Liquid
810.9
13.17
126.50
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
DIE
011
003004
103CS1P
10"-DIE-011037003-103CS1P-H
Insul Brk
-
-
H
40
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
DIE
011
003004
103CS1P
Insul Brk
2"-CLD-011003315-101CH2S-P
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
DIE
011
003004
103CS1P
2"-DIE-011003004-103CS1P-P
Blind flange
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480007
8"
DIE
011
004001
103CS1P
011-E-0006
Reducer
-
-
H
50
LAGO
Liquid
772.2
13.10
109.00
-
-
20.00
205.00
-
H
30.02
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480007
6"
DIE
011
004001
103CS1P
Reducer
SA-JER-DS011-TRJR-480110
-
-
H
50
LAGO
Liquid
772.2
13.10
109.00
-
-
20.00
205.00
-
H
30.02
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480007
2"
DIE
011
004001
103CS1P
6"-DIE-011004001-103CS1P-H
011-TT-0026
-
-
H
40
LAGO
Liquid
772.2
13.10
109.00
-
-
20.00
205.00
-
H
30.02
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480110
6"
DIE
011
004001
103CS1P
SA-JER-DS011-TRJR-480007
Reducer
-
-
H
50
LAGO
Liquid
772.2
13.10
109.00
-
-
20.00
205.00
-
H
30.02
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480110
8"
DIE
011
004001
103CS1P
Reducer
011-E-0024
-
-
H
50
LAGO
Liquid
772.2
13.10
109.00
-
-
20.00
205.00
-
H
30.02
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480007
3/4"
DIE
011
004002
103CS1P
6"-DIE-011004001-103CS1P-H
Insul Brk
-
-
H
25
LAGO
Liquid
772.2
13.10
109.00
-
-
20.00
205.00
-
H
30.02
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480007
3/4"
DIE
011
004002
103CS1P
Insul Brk
Reducer
-
-
P
25
LAGO
Liquid
772.2
13.10
109.00
-
-
20.00
205.00
-
H
30.02
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480007
3/4"
DIE
011
004002
103CS1P
3/4"-DIE-011004002-103CS1P-P
Plug
-
-
P
25
LAGO
Liquid
772.2
13.10
109.00
-
-
20.00
205.00
-
H
30.02
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480007
2"
DIE
011
004002
103CS1P
Reducer
2"-CLD-011004307-101CH2S-P
-
-
P
25
LAGO
Liquid
772.2
13.10
109.00
-
-
20.00
205.00
-
H
30.02
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
8"
DIE
011
009001
103CS1P
011-E-0011-B
Reducer
-
-
H
65
LAGO
Liquid
729.8
13.20
171.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
6"
DIE
011
009001
103CS1P
Reducer
SA-JER-DS011-TRJR-480007
-
-
H
50
LAGO
Liquid
729.8
13.20
171.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480007
6"
DIE
011
009001
103CS1P
SA-JER-DS011-TRJR-480017
Reducer
-
-
H
50
LAGO
Liquid
729.8
13.20
171.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480007
8"
DIE
011
009001
103CS1P
Reducer
011-E-0006
-
-
H
65
LAGO
Liquid
729.8
13.20
171.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480017
3/4"
DIE
011
009002
103CS1P
6"-DIE-011009001-103CS1P-H
Insul Brk
-
-
H
40
LAGO
Liquid
729.8
13.20
171.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
3/4"
DIE
011
009002
103CS1P
Insul Brk
Reducer
-
-
P
25
LAGO
Liquid
729.8
13.20
171.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
3/4"
DIE
011
009002
103CS1P
3/4"-DIE-011009002-103CS1P-P
Plug
-
-
P
25
LAGO
Liquid
729.8
13.20
171.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
2"
DIE
011
009002
103CS1P
Reducer
2"-CLD-011009305-101CH2S-P
-
-
P
25
LAGO
Liquid
729.8
13.20
171.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Y
POTENTIAL
N
N
N
N
-
NOTE 6
if insulated N or Q SA-JER-DS011-TRJR-480017
-
DIE
011
009601
103CS1P
TRIM
-
-
H
-
-
-
-
13.30
234.00
-
-
33.10
265.00
-
Visual Test
0.00
NFS
By Code
SA-JER-DS011-TRJR-480018
18"
DIE
011
010001
103CS1P
SA-JER-DS011-TRJR-480018
16"
DIE
011
010001
103CS1P
SA-JER-DS011-TRJR-480018
2"
DIE
011
010001
103CS1P
011-E-0013
Reducer
-
-
H
100
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
Reducer
SA-JER-DS011-TRJR-480140
-
-
H
100
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
16"-DIE-011010001-103CS1P-H
011-TT-0051
-
-
H
50
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480018
3/4"
DIE
011
010001
103CS1P
NOTE 6.
16"-DIE-011010001-103CS1P-H
011-PDT-0111
-
-
H
40
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480018
2"
DIE
011
010001
NOTE 6.
103CS1P
16"-DIE-011010001-103CS1P-H
011-TI-0047
-
-
H
50
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480140
16"
DIE
011
NOTE 6.
010001
103CS1P
SA-JER-DS011-TRJR-480018
SA-JER-DS111-TRJR-480042
-
-
H
100
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480140
3/4"
DIE
NOTE 6
011
010001
103CS1P
16"-DIE-011010001-103CS1P-H
011-PI-0170
-
-
H
40
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480140
2"
NOTE 6
DIE
011
010001
103CS1P
16"-DIE-011010001-103CS1P-H
Blind flange
-
-
H
50
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480018 SA-JER-DS011-TRJR-480018
NOTE 6
12"
DIE
011
010002
103CS2P
16"-DIE-011026003-103CS2P-H
Reducer
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
12"
DIE
011
010002
103CS2P
12"-DIE-011010002-103CS2P-H
Reducer
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480018
10"
DIE
011
010002
103CS2P
Reducer
10"-DIE-011010004-103CS1P-H
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480018
10"
DIE
011
010002
103CS2P
Reducer
Reducer
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480018
12"
DIE
011
010002
103CS2P
Reducer
12"-DIE-011010004-103CS1P-H
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480018
3/4"
DIE
011
010003
103CS2P
12"-DIE-011010002-103CS2P-H
Insul Brk
-
-
H
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480018
3/4"
DIE
011
010003
103CS2P
Insul Brk
Reducer
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480018
3/4"
DIE
011
010003
103CS2P
3/4"-DIE-011010003-103CS2P-P
Plug
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480018
2"
DIE
011
010003
103CS2P
Reducer
2"-CLD-011010301-101CH2S-P
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480018
3/4"
DIE
011
010003
103CS2P
12"-DIE-011010002-103CS2P-H
Insul Brk
-
-
H
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480018
3/4"
DIE
011
010003
103CS2P
Insul Brk
3/4"-DIE-011010003-103CS2P-P
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480018
12"
DIE
011
010004
103CS1P
12"-DIE-011010002-103CS2P-H
16"-DIE-011010001-103CS1P-H
-
-
H
100
LAGO
Liquid
661
11.00
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480018
12"
DIE
011
010004
103CS1P
Reducer
12"-DIE-011010004-103CS1P-H
-
-
H
100
LAGO
Liquid
661
11.00
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480018
10"
DIE
011
010004
103CS1P
10"-DIE-011010002-103CS2P-H
Reducer
-
-
H
100
LAGO
Liquid
661
11.00
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480018
2"
DIE
011
010005
103CS1P
16"-DIE-011010001-103CS1P-H
Insul Brk
-
-
H
50
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480018
2"
DIE
011
010005
103CS1P
Insul Brk
2"-CLD-011010304-101CH2S-P
-
-
P
40
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480018
2"
DIE
011
010005
103CS1P
2"-DIE-011010005-103CS1P-P
Blind flange
-
-
P
40
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480018
3/4"
DIE
011
010006
103CS2P
16"-DIE-011026003-103CS2P-H
Insul Brk
-
-
H
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480018
3/4"
DIE
011
010006
103CS2P
Insul Brk
Reducer
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480018
3/4"
DIE
011
010006
103CS2P
3/4"-DIE-011010006-103CS2P-P
Plug
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480018
2"
DIE
011
010006
103CS2P
Reducer
2"-CLD-011010301-101CH2S-P
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
28"
DIE
011
018001
101CS2P
011-C-0002
SA-JER-DS011-TRJR-480054
-
-
H
100
LAGO
Liquid
661
4.10
245.00
-
-
6.40
275.00
-
H
10.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
011-E-0011-A/B
if NOT insulated C or Q
NOTE 6
Page 65 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
TO
TYPE
INSULATION (NOTE 2)
TEMP. (ºC)
TYPE
FLUID
THICKNESS (mm)
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480044
2"
DIE
011
018001
101CS2P
28"-DIE-011018001-101CS2P-H
011-TT-0106
-
-
H
65
LAGO
Liquid
661
4.10
245.00
-
-
6.40
275.00
-
H
10.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
28"
DIE
011
018001
101CS2P
011-C-0002
28"-DIE-011018001-101CS2P-H
-
-
H
100
LAGO
Liquid
661
4.10
245.00
-
-
6.40
275.00
-
H
10.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480054
28"
DIE
011
018001
101CS2P
SA-JER-DS011-TRJR-480044
Reducer
-
-
H
100
LAGO
Liquid
661
4.10
245.00
-
-
6.40
275.00
-
H
10.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480054
26"
DIE
011
018001
101CS2P
Reducer
SA-JER-DS011-TRJR-480064
-
-
H
100
LAGO
Liquid
661
4.10
245.00
-
-
6.40
275.00
-
H
10.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
26"
DIE
011
018001
101CS2P
SA-JER-DS011-TRJR-480054
Reducer
-
-
H
100
LAGO
Liquid
661
4.10
245.00
-
-
6.40
275.00
-
H
10.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
20"
DIE
011
018001
101CS2P
Reducer
20"-DIE-011026001-103CS2P-H
-
-
H
100
LAGO
Liquid
661
4.10
245.00
-
-
6.40
275.00
-
H
10.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
26"
DIE
011
018001
101CS2P
26"-DIE-011018001-101CS2P-H
Reducer
-
-
H
100
LAGO
Liquid
661
4.10
245.00
-
-
6.40
275.00
-
H
10.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
20"
DIE
011
018001
101CS2P
Reducer
20"-DIE-011026002-103CS2P-H
-
-
H
100
LAGO
Liquid
661
4.10
245.00
-
-
6.40
275.00
-
H
10.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
8"
DIE
011
018002
101CS2P
8"-DIE-011026004-103CS2P-H
011-C-0002
-
-
H
100
LAGO
Liquid
661
4.30
247.00
-
-
6.60
390.00
-
H
14.02
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
8"
DIE
011
018002
101CS2P
Reducer
8"-DIE-011018002-101CS2P-H
-
-
H
100
LAGO
Liquid
661
4.30
247.00
-
-
6.60
390.00
-
H
14.02
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
4"
DIE
011
018002
101CS2P
4"-DIE-011026004-103CS2P-H
Reducer
-
-
H
65
LAGO
Liquid
661
4.30
247.00
-
-
6.60
390.00
-
H
14.02
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
16"
DIE
011
018003
101CS1P
16"-DIE-011098001-103CS1P-H
Reducer
-
-
H
100
LAGO
Liquid
708
4.70
201.00
-
-
6.20
280.00
-
H
10.15
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
4"
DIE
011
018003
101CS1P
4"-DIE-011018003-101CS1P-P
Insul Brk
-
-
H
50
LAGO
Liquid
708
4.70
201.00
-
-
6.20
280.00
-
H
10.15
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
16"
DIE
011
018003
101CS1P
16"-DIE-011018003-101CS1P-H
Reducer
-
-
H
100
LAGO
Liquid
708
4.70
201.00
-
-
6.20
280.00
-
H
10.15
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
14"
DIE
011
018003
101CS1P
Reducer
16"-DIE-011018003-101CS1P-H
-
-
H
65
LAGO
Liquid
708
4.70
201.00
-
-
6.20
280.00
-
H
10.15
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
10"
DIE
011
018003
101CS1P
10"-DIE-011098001-103CS1P-H
Reducer
-
-
H
65
LAGO
Liquid
708
4.70
201.00
-
-
6.20
280.00
-
H
10.15
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
3/4"
DIE
011
018003
101CS1P
4"-DIE-011018003-101CS1P-P
Plug
-
-
H
40
LAGO
Liquid
708
4.70
201.00
-
-
6.20
280.00
-
H
10.15
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
4"
DIE
011
018003
101CS1P
Insul Brk
16"-DIE-011018003-101CS1P-H
-
-
H
50
LAGO
Liquid
708
4.70
201.00
-
-
6.20
280.00
-
H
10.15
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
12"
DIE
011
018003
101CS1P
Reducer
011-C-0002
-
-
H
65
LAGO
Liquid
708
4.70
201.00
-
-
6.20
280.00
-
H
10.15
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
12"
DIE
011
018003
101CS1P
Reducer
011-C-0002
-
-
H
65
LAGO
Liquid
708
4.70
201.00
-
-
6.20
280.00
-
H
10.15
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
4"
DIE
011
018003
101CS1P
4"-FLO-011018302-101CS1P-N
4"-DIE-011018003-101CS1P-P
-
-
P
40
FLUSHING OIL
Liquid
850
4.70
201.00
-
-
6.20
280.00
-
H
10.15
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
16"
DIE
011
018003
101CS1P
3"-NAP-011098001-103CH2S-P
16"-DIE-011018003-101CS1P-H
-
-
H
100
LAGO
Liquid
708
4.70
201.00
-
-
6.20
280.00
-
H
10.15
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
3/4"
DIE
011
018004
103CS1P
16"-DIE-011098001-103CS1P-H
Insul Brk
-
-
H
40
LAGO
Liquid
708
8.10
201.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
3/4"
DIE
011
018004
103CS1P
Insul Brk
Reducer
-
-
P
25
LAGO
Liquid
708
8.10
201.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
3/4"
DIE
011
018004
103CS1P
3/4"-DIE-011018004-103CS1P-P
Plug
-
-
P
25
LAGO
Liquid
708
8.10
201.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
2"
DIE
011
018004
103CS1P
Reducer
2"-CLD-011018301-101CH2S-P
-
-
P
25
LAGO
Liquid
708
8.10
201.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
3/4"
DIE
011
018005
103CS2P
8"-DIE-011026004-103CS2P-H
Insul Brk
-
-
H
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
3/4"
DIE
011
018005
103CS2P
Insul Brk
Reducer
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
3/4"
DIE
011
018005
103CS2P
3/4"-DIE-011018005-103CS2P-P
Blind flange
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
2"
DIE
011
018005
103CS2P
Reducer
2"-CLD-011018309-101CH2S-P
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
3/4"
DIE
011
018005
103CS2P
8"-DIE-011026004-103CS2P-H
Insul Brk
-
-
H
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
3/4"
DIE
011
018005
103CS2P
Insul Brk
3/4"-DIE-011018005-103CS2P-P
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
3/4"
DIE
011
018008
101CS2P
011-LG-0014
Reducer
-
-
P
40
LAGO
Liquid
659
1.20
247.30
-
-
4.10
297.00
-
H
6.90
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
3/4"
DIE
011
018008
101CS2P
3/4"-DIE-011018008-101CS2P-P
Blind flange
-
-
P
40
LAGO
Liquid
659
1.20
247.30
-
-
4.10
297.00
-
H
6.90
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
2"
DIE
011
018008
101CS2P
Reducer
2"-CLD-011018303-101CH2S-P
-
-
P
40
LAGO
Liquid
659
1.20
247.30
-
-
4.10
297.00
-
H
6.90
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
3/4"
DIE
011
018009
101CS2P
011-LG-0014
3/4"-LFL-011018303-101CH2F-N
-
-
P
40
LAGO
Gas
-
1.20
268.70
-
-
4.10
297.00
-
H
6.90
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
3/4"
DIE
011
018009
101CS2P
3/4"-DIE-011018009-101CS2P-P
Blind flange
-
-
P
40
LAGO
Gas
-
1.20
268.70
-
-
4.10
297.00
-
H
6.90
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
if insulated M or Q SA-JER-DS011-TRJR-480044
-
DIE
011
018601
103CS2P
011-C-0002
TRIM
-
-
H
-
-
-
-
1.00
119.00
-
-
3.50
280.00
-
Visual Test
0.00
NFS
By Code
SA-JER-DS011-TRJR-480044
2"
DIE
011
018601
103CS2P
011-C-0002
011-LG-0014
-
-
H
40
-
-
-
1.00
119.00
-
-
3.50
280.00
-
H
5.73
NFS
By Code
SA-JER-DS011-TRJR-480044
2"
DIE
011
018601
103CS2P
011-C-0002
011-LT-0013
-
-
H
40
-
-
-
1.00
119.00
-
-
3.50
280.00
-
H
5.73
NFS
By Code
SA-JER-DS011-TRJR-480044
2"
DIE
011
018601
103CS2P
011-C-0002
011-LG-0014
-
-
H
40
-
-
-
1.00
119.00
-
-
3.50
280.00
-
H
5.73
NFS
By Code
SA-JER-DS011-TRJR-480044
2"
DIE
011
018601
103CS2P
011-LT-0015
011-C-0002
-
-
H
40
-
-
-
1.00
119.00
-
-
3.50
280.00
-
H
5.73
NFS
By Code
SA-JER-DS011-TRJR-480044
2"
DIE
011
018601
103CS2P
011-C-0002
011-LT-0013
-
-
H
40
-
-
-
1.00
119.00
-
-
3.50
280.00
-
H
5.73
NFS
By Code
SA-JER-DS011-TRJR-480044
2"
DIE
011
018601
103CS2P
011-LT-0015
011-C-0002
-
-
H
40
-
-
-
1.00
119.00
-
-
3.50
280.00
-
H
5.73
NFS
By Code
SA-JER-DS011-TRJR-480054
10"
DIE
011
023001
101CS2P
28"-DIE-011018001-101CS2P-H
Reducer
-
-
H
100
LAGO
Liquid
661
4.10
245.00
-
-
6.40
275.00
-
H
10.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480054
6"
DIE
011
023001
101CS2P
Reducer
6"-DIE-011023001-101CS2P-H
-
-
H
100
LAGO
Liquid
661
4.10
245.00
-
-
6.40
275.00
-
H
10.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480054
8"
DIE
011
023001
101CS2P
10"-DIE-011023001-101CS2P-H
Reducer
-
-
H
100
LAGO
Liquid
661
4.10
245.00
-
-
6.40
275.00
-
H
10.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480054
6"
DIE
011
023001
101CS2P
Reducer
Reducer
-
-
H
100
LAGO
Liquid
661
4.10
245.00
-
-
6.40
275.00
-
H
10.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480054
10"
DIE
011
023001
101CS2P
Reducer
10"-DIE-011023001-101CS2P-H
-
-
H
100
LAGO
Liquid
661
4.10
245.00
-
-
6.40
275.00
-
H
10.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480054
10"
DIE
011
023001
101CS2P
10"-DIE-011023001-101CS2P-H
011-C-0005
-
-
H
100
LAGO
Liquid
661
1.35
245.00
-
-
3.80
370.00
-
H
6.90
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480054
6"
DIE
011
023001
101CS2P
6"-DIE-011023001-101CS2P-H
Reducer
-
-
H
100
LAGO
Liquid
661
1.35
245.00
-
-
3.80
370.00
-
H
6.90
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480054
8"
DIE
011
023001
101CS2P
Reducer
10"-DIE-011023001-101CS2P-H
-
-
H
100
LAGO
Liquid
661
1.35
245.00
-
-
3.80
370.00
-
H
6.90
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480054
14"
DIE
011
023002
101CS2P
011-C-0005
SA-JER-DS011-TRJR-480043
-
-
H
100
LAGO
Gas
-
1.20
243.00
-
-
3.80
370.00
-
H
6.90
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
SA-JER-DS011-TRJR-480054
2"
DIE
011
023002
101CS2P
14"-DIE-011023002-101CS2P-H
011-TT-0125
-
-
H
65
LAGO
Gas
-
1.20
243.00
-
-
3.80
370.00
-
H
6.90
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480054
3/4"
DIE
011
023002
101CS2P
14"-DIE-011023002-101CS2P-H
011-PI-0049
-
-
H
40
LAGO
Gas
-
1.20
243.00
-
-
3.80
370.00
-
H
6.90
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
14"
DIE
011
023002
101CS2P
SA-JER-DS011-TRJR-480054
011-C-0002
-
-
H
100
LAGO
Gas
-
1.20
243.00
-
-
3.80
370.00
-
H
6.90
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480054
12"
DIE
011
023003
101CS2P
011-C-0005
SA-JER-DS011-TRJR-480055
-
-
H
100
LAGO
Liquid
680
1.30
234.00
-
-
5.70
370.00
-
H
10.35
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480054
2"
DIE
011
023003
101CS2P
12"-DIE-011023003-101CS2P-H
011-TT-0126
-
-
H
65
LAGO
Liquid
680
1.30
234.00
-
-
5.70
370.00
-
H
10.35
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
12"
DIE
011
023003
101CS2P
SA-JER-DS011-TRJR-480054
12"-DIE-011023003-101CS2P-H
-
-
H
100
LAGO
Liquid
680
1.30
234.00
-
-
5.70
370.00
-
H
10.35
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
12"
DIE
011
023003
101CS2P
12"-DIE-011023003-101CS2P-H
12"-DIE-011023004-103CS2P-H
-
-
H
100
LAGO
Liquid
680
1.30
234.00
-
-
5.70
370.00
-
H
10.35
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
12"
DIE
011
023003
101CS2P
12"-DIE-011023003-101CS2P-H
12"-DIE-011023005-103CS2P-H
-
-
H
100
LAGO
Liquid
680
1.30
234.00
-
-
5.70
370.00
-
H
10.35
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
12"
DIE
011
023004
103CS2P
12"-DIE-011023003-101CS2P-H
Reducer
-
-
H
100
LAGO
Liquid
680
1.30
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
3/4"
DIE
011
023004
103CS2P
12"-DIE-011023004-103CS2P-H
011-PI-0218
-
-
H
40
LAGO
Liquid
680
1.30
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
2"
DIE
011
023004
103CS2P
12"-DIE-011023004-103CS2P-H
UC
-
-
H
65
LAGO
Liquid
680
1.30
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
6"
DIE
011
023004
103CS2P
Reducer
011-G-0011-A
-
-
H
100
LAGO
Liquid
680
1.30
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
12"
DIE
011
023005
103CS2P
12"-DIE-011023003-101CS2P-H
Reducer
-
-
H
100
LAGO
Liquid
680
1.30
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
2"
DIE
011
023005
103CS2P
12"-DIE-011023005-103CS2P-H
UC
-
-
H
65
LAGO
Liquid
680
1.30
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
3/4"
DIE
011
023005
103CS2P
12"-DIE-011023005-103CS2P-H
011-PI-0220
-
-
H
40
LAGO
Liquid
680
1.30
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
6"
DIE
011
023005
103CS2P
Reducer
011-G-0011-B
-
-
H
100
LAGO
Liquid
680
1.30
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
4"
DIE
011
023006
103CS2P
011-G-0011-A
Reducer
-
-
H
65
LAGO
Liquid
680.3
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
6"
DIE
011
023006
103CS2P
Reducer
SA-JER-DS011-TRJR-480017
-
-
H
100
LAGO
Liquid
680.3
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
3/4"
DIE
011
023006
103CS2P
6"-DIE-011023006-103CS2P-H
011-PI-0051
-
-
H
40
LAGO
Liquid
680.3
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 66 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
FLUID
THICKNESS (mm)
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480055
3/4"
DIE
011
023006
103CS2P
6"-DIE-011023006-103CS2P-H
6"-DIE-011023006-103CS2P-H
-
-
H
40
LAGO
Liquid
680.3
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
6"
DIE
011
023006
103CS2P
SA-JER-DS011-TRJR-480055
Reducer
-
-
H
100
LAGO
Liquid
680.3
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
8"
DIE
011
023006
103CS2P
Reducer
011-E-0011-A
-
-
H
100
LAGO
Liquid
680.3
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
1/2"
DIE
011
023006
103CS2P
011-PI-0051
1/2"-DIE-011023006-103CS2P-P
-
-
P
25
LAGO
Liquid
680
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480250
1/2"
DIE
011
023006
103CS2P
SA-JER-DS011-TRJR-480055
2"-OLW-011171301-101CS1P-N
-
-
P
25
LAGO
Liquid
680
0.00
27.00
-
-
0.00
60.00
-
H
0.00
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
1/2"
DIE
011
023006
103CS2P
1/2"-DIE-011023006-103CS2P-P
SA-JER-DS011-TRJR-480250
-
-
P
25
LAGO
Liquid
680
0.00
27.00
-
-
0.00
60.00
-
H
0.00
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480054
3/4"
DIE
011
023007
101CS2P
011-LG-0037-A
Reducer
-
-
P
40
LAGO
Liquid
680
1.30
234.00
-
-
5.70
370.00
-
H
10.35
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
-
-
P
40
LAGO
Liquid
680
1.30
234.00
-
-
5.70
370.00
-
H
10.35
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480054
3/4"
DIE
011
023007
101CS2P
3/4"-DIE-011023007-101CS2P-P
3/4"-OLW-011023303-101CS1PN
SA-JER-DS011-TRJR-480054
2"
DIE
011
023007
101CS2P
Reducer
2"-CLD-011023302-101CH2S-P
-
-
P
40
LAGO
Liquid
680
1.30
234.00
-
-
5.70
370.00
-
H
10.35
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480054
3/4"
DIE
011
023007
101CS2P
011-LG-0037-B
3/4"-DIE-011023007-101CS2P-P
-
-
P
40
LAGO
Liquid
680
1.30
234.00
-
-
5.70
370.00
-
H
10.35
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480054
3/4"
DIE
011
023009
101CS2P
10"-DIE-011023001-101CS2P-H
Insul Brk
-
-
H
40
LAGO
Liquid
661
4.10
245.00
-
-
6.40
275.00
-
H
10.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480054
3/4"
DIE
011
023009
101CS2P
Insul Brk
Reducer
-
-
P
40
LAGO
Liquid
661
4.10
245.00
-
-
6.40
275.00
-
H
10.40
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480054
3/4"
DIE
011
023009
101CS2P
3/4"-DIE-011023009-101CS2P-P
Plug
-
-
P
40
LAGO
Liquid
661
4.10
245.00
-
-
6.40
275.00
-
H
10.40
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480054
2"
DIE
011
023009
101CS2P
Reducer
2"-CLD-011023301-101CH2S-P
-
-
P
40
LAGO
Liquid
661
4.10
245.00
-
-
6.40
275.00
-
H
10.40
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480054
3/4"
DIE
011
023009
101CS2P
10"-DIE-011023001-101CS2P-H
Insul Brk
-
-
H
40
LAGO
Liquid
661
4.10
245.00
-
-
6.40
275.00
-
H
10.40
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480054
3/4"
DIE
011
023009
101CS2P
Insul Brk
3/4"-DIE-011023009-101CS2P-P
-
-
P
40
LAGO
Liquid
661
4.10
245.00
-
-
6.40
275.00
-
H
10.40
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480054
3"
DIE
011
023011
101CS2P
011-C-0005
3"-OLW-011023304-101CS1P-N
-
-
P
40
LAGO
Liquid
680
1.30
234.00
-
-
5.70
370.00
-
H
10.35
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
1-1/2"
DIE
011
023012
103CS2P
Insul Brk
-
-
H
50
LAGO
Liquid
680.3
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
1-1/2"
DIE
011
023012
103CS2P
Insul Brk
Reducer
-
-
P
40
LAGO
Liquid
680.3
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
3/4"-OLW-011023301-101CS1PN
-
-
P
40
LAGO
Liquid
680.3
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
2"-CLD-011023303-101CH2S-P
-
-
P
40
LAGO
Liquid
680.3
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
6"-DIE-011023006-103CS2P-H
SA-JER-DS011-TRJR-480055
3/4"
DIE
011
023012
103CS2P
1-1/2"-DIE-011023012-103CS2PP
SA-JER-DS011-TRJR-480055
2"
DIE
011
023012
103CS2P
Reducer
SA-JER-DS011-TRJR-480055
1-1/2"
DIE
011
023012
103CS2P
12"-DIE-011023004-103CS2P-H
Insul Brk
-
-
H
50
LAGO
Liquid
680.3
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
1-1/2"-DIE-011023012-103CS2PP
-
-
P
40
LAGO
Liquid
680.3
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
1-1/2"
DIE
011
023012
103CS2P
Insul Brk
SA-JER-DS011-TRJR-480055
3/4"
DIE
011
023012
103CS2P
011-G-0011-A
Reducer
-
-
P
40
LAGO
Liquid
680.3
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
40
LAGO
Liquid
680.3
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
1"
DIE
011
023012
103CS2P
Reducer
1-1/2"-DIE-011023012-103CS2PP
SA-JER-DS011-TRJR-480055
1-1/2"
DIE
011
023013
103CS2P
6"-DIE-011023014-103CS2P-H
Insul Brk
-
-
H
50
LAGO
Liquid
680
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
1-1/2"
DIE
011
023013
103CS2P
Insul Brk
Reducer
-
-
P
40
LAGO
Liquid
680
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
3/4"-OLW-011023302-101CS1PN
-
-
P
40
LAGO
Liquid
680
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
3/4"
DIE
011
023013
103CS2P
1-1/2"-DIE-011023013-103CS2PP
SA-JER-DS011-TRJR-480055
2"
DIE
011
023013
103CS2P
Reducer
2"-CLD-011023304-101CH2S-P
-
-
P
40
LAGO
Liquid
680
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
1-1/2"
DIE
011
023013
103CS2P
12"-DIE-011023005-103CS2P-H
Insul Brk
-
-
H
50
LAGO
Liquid
680
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
1-1/2"
DIE
011
023013
103CS2P
Insul Brk
1-1/2"-DIE-011023013-103CS2PP
-
-
P
40
LAGO
Liquid
680
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
3/4"
DIE
011
023013
103CS2P
011-G-0011-B
Reducer
-
-
P
40
LAGO
Liquid
680
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
1"
DIE
011
023013
103CS2P
Reducer
1-1/2"-DIE-011023013-103CS2PP
-
-
P
40
LAGO
Liquid
680
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
4"
DIE
011
023014
103CS2P
011-G-0011-B
Reducer
-
-
H
65
LAGO
Liquid
680.3
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
6"
DIE
011
023014
103CS2P
Reducer
6"-DIE-011023006-103CS2P-H
-
-
H
100
LAGO
Liquid
680.3
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
3/4"
DIE
011
023014
103CS2P
6"-DIE-011023014-103CS2P-H
6"-DIE-011023014-103CS2P-H
-
-
H
40
LAGO
Liquid
680.3
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
3/4"
DIE
011
023014
103CS2P
6"-DIE-011023014-103CS2P-H
011-PI-0052
-
-
H
40
LAGO
Liquid
680.3
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
1/2"
DIE
011
023014
103CS2P
011-PI-0052
1/2"-DIE-011023014-103CS2P-P
-
-
P
25
LAGO
Liquid
680
13.95
234.00
-
-
20.00
265.00
-
H
31.99
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
25
LAGO
Liquid
680
0.00
27.00
-
-
0.00
60.00
-
H
0.00
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480055
1/2"
DIE
011
023014
103CS2P
1/2"-DIE-011023014-103CS2P-P
3/4"-OLW-011023302-101CS1PN
SA-JER-DS011-TRJR-480054
3/4"
DIE
011
023016
101CS1P
011-LG-0037-A
3/4"-LFL-011023301-101CH2F-N
-
-
P
40
LAGO
Gas
-
1.30
243.00
-
-
3.90
370.00
-
H
7.08
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480054
3/4"
DIE
011
023016
101CS1P
3/4"-DIE-011023016-101CS1P-P
Plug
-
-
P
40
LAGO
Gas
-
1.30
243.00
-
-
3.90
370.00
-
H
7.08
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480054
3/4"
DIE
011
023016
101CS1P
011-LG-0037-B
3/4"-DIE-011023016-101CS1P-P
-
-
P
40
LAGO
Gas
-
1.30
243.00
-
-
3.90
370.00
-
H
7.08
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480054
2"
DIE
011
023017
101CS2P
UC
011-C-0005
-
-
P
40
LAGO
Liquid
680
1.30
234.00
-
-
3.90
370.00
-
H
7.08
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: 7 BARG+FV@290ºC.
SA-JER-DS011-TRJR-480054
3/4"
DIE
011
023017
101CS2P
2"-DIE-011023017-101CS2P-P
Plug
-
-
P
40
LAGO
Liquid
680
1.30
234.00
-
-
3.90
370.00
-
H
7.08
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: 7 BARG+FV@290ºC.
SA-JER-DS011-TRJR-480054
-
DIE
011
023601
103CS2P
011-C-0005
TRIM
-
-
H
-
-
-
-
1.30
234.00
-
-
3.90
370.00
-
Visual Test
0.00
NFS
By Code
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150ºC
SA-JER-DS011-TRJR-480054
-
DIE
011
023602
101CS2P
011-C-0005
TRIM
-
-
H
-
-
-
-
1.20
243.00
-
-
3.90
370.00
-
Visual Test
0.00
NFS
By Code
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150ºC
SA-JER-DS011-TRJR-480059
6"
DIE
011
025001
103CS1P
011-A-0003-A/B
SA-JER-DS011-TRJR-480060
-
-
P
25
LAGO
Liquid
800
10.50
65.00
-
-
20.00
140.00
-
H
30.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480059
6"
DIE
011
025001
103CS1P
011-A-0003-A/B
6"-DIE-011025001-103CS1P-P
-
-
P
25
LAGO
Liquid
800
10.50
65.00
-
-
20.00
140.00
-
H
30.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
6"
DIE
011
025001
103CS1P
SA-JER-DS011-TRJR-480059
Reducer
-
-
P
25
LAGO
Liquid
800
10.50
65.00
-
-
20.00
140.00
-
H
30.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
8"
DIE
011
025001
103CS1P
Reducer
011-E-0034
-
-
P
25
LAGO
Liquid
800
10.50
65.00
-
-
20.00
140.00
-
H
30.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
8"
DIE
011
025002
103CS1P
011-E-0034
Reducer
-
-
N
-
LAGO
Liquid
809.6
11.10
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
6"
DIE
011
025002
103CS1P
Reducer
Reducer
-
-
N
-
LAGO
Liquid
809.6
11.10
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480133
6"
DIE
011
025002
103CS1P
SA-JER-DS011-TRJR-480060
6"-DIE-011025002-103CS1P-N
-
-
N
-
LAGO
Liquid
809.6
7.00
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480133
6"
DIE
011
025002
103CS1P
6"-DIE-011025002-103CS1P-N
IP-1315-L
-
-
N
-
LAGO
Liquid
854
7.00
50.00
-
-
23.30
80.00
-
H
34.95
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
4"
DIE
011
025002
103CS1P
Reducer
Reducer
-
-
N
-
LAGO
Liquid
809.6
11.10
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
6"
DIE
011
025002
103CS1P
6"-DIE-011025002-103CS1P-N
SA-JER-DS011-TRJR-480133
-
-
N
-
LAGO
Liquid
809.6
7.00
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
6"
DIE
011
025002
103CS1P
Reducer
6"-DIE-011025002-103CS1P-N
-
-
N
-
LAGO
Liquid
809.6
11.10
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480062
6"
DIE
011
025003
103CS1P
6"-HFO-011025002-103CS1P-N
SA-JER-DS011-TRJR-480132
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
6"
DIE
011
025003
103CS1P
SA-JER-DS011-TRJR-480062
Reducer
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q
SA-JER-DS011-TRJR-480132
8"
DIE
011
025003
103CS1P
Reducer
IP-1310-L
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480059
1-1/2"
DIE
011
025004
103CS1P
011-A-0003-A/B
SA-JER-DS011-TRJR-480061
-
-
P
25
LAGO
Liquid
800
10.50
65.00
-
-
20.00
140.00
-
H
30.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
25
LAGO
Liquid
800
10.50
65.00
-
-
20.00
140.00
-
H
30.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
25
LAGO
Liquid
800
10.50
65.00
-
-
20.00
140.00
-
H
30.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
1-1/2"-DIE-011025004-103CS1PP 1-1/2"-HFO-011025012-103CS1PP
SA-JER-DS011-TRJR-480059
1-1/2"
DIE
011
025004
103CS1P
011-A-0003-A/B
SA-JER-DS011-TRJR-480061
1-1/2"
DIE
011
025004
103CS1P
SA-JER-DS011-TRJR-480059
SA-JER-DS011-TRJR-480060
3/4"
DIE
011
025005
103CS1P
6"-DIE-011025002-103CS1P-N
Reducer
-
-
N
-
LAGO
Liquid
809.6
11.10
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
2"
DIE
011
025005
103CS1P
Reducer
2"-CLD-011025303-101CH2S-P
-
-
N
-
LAGO
Liquid
809.6
11.10
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
3/4"
DIE
011
025005
103CS1P
6"-DIE-011025002-103CS1P-N
3/4"-DIE-011025005-103CS1P-N
-
-
N
-
LAGO
Liquid
809.6
11.10
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
3/4"
DIE
011
025006
103CS1P
6"-DIE-011025002-103CS1P-N
011-SC-0003
-
-
N
-
LAGO
Liquid
809.6
11.10
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
3/4"
DIE
011
025007
103CS1P
011-SC-0003
6"-DIE-011025002-103CS1P-N
-
-
N
-
LAGO
Liquid
854
7.00
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
3/4"
DIE
011
025010
103CS1P
6"-DIE-011025002-103CS1P-N
Reducer
-
-
N
-
LAGO
Liquid
809.6
11.10
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
2"
DIE
011
025010
103CS1P
Reducer
2"-CLD-011025315-101CH2S-P
-
-
N
-
LAGO
Liquid
809.6
11.10
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
3/4"
DIE
011
025011
103CS1P
6"-DIE-011025015-103CS1P-N
Reducer
-
-
N
-
LAGO
Liquid
809.6
11.10
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
2"
DIE
011
025011
103CS1P
Reducer
2"-CLD-011025304-101CH2S-P
-
-
N
-
LAGO
Liquid
809.6
11.10
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
3/4"
DIE
011
025011
103CS1P
6"-DIE-011025015-103CS1P-N
3/4"-DIE-011025011-103CS1P-N
-
-
N
-
LAGO
Liquid
809.6
11.10
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480059
3/4"
DIE
011
025013
103CS1P
6"-DIE-011043001-103CS1P-P
3/4"-LFL-011025301-101CH2F-N
-
-
P
25
LAGO
Gas
-
12.60
85.50
-
-
20.00
140.00
-
H
30.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480059
3/4"
DIE
011
025013
103CS1P
3/4"-DIE-011025013-103CS1P-P
Plug
-
-
P
25
LAGO
Gas
-
12.60
85.50
-
-
20.00
140.00
-
H
30.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
2"
DIE
011
025014
103CS1P
2"-PRO-011033008-103CH2S-N
6"-DIE-011025015-103CS1P-N
-
-
N
-
LAGO
Liquid
809.6
7.00
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
6"
DIE
011
025015
103CS1P
6"-DIE-011025002-103CS1P-N
Reducer
-
-
N
-
LAGO
Liquid
809.6
11.10
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
4"
DIE
011
025015
103CS1P
Reducer
Reducer
-
-
N
-
LAGO
Liquid
809.6
11.10
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480133
6"
DIE
011
025015
103CS1P
SA-JER-DS011-TRJR-480060
IP-1302-L
-
-
N
-
LAGO
Liquid
854
7.00
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
6"
DIE
011
025015
103CS1P
Reducer
6"-DIE-011025015-103CS1P-N
-
-
N
-
LAGO
Liquid
809.6
11.10
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
6"-DIE-011025015-103CS1P-N
SA-JER-DS011-TRJR-480133
-
-
N
-
LAGO
Liquid
809.6
7.00
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
100
LAGO
Liquid
661
4.10
245.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
65
LAGO
Liquid
661
4.10
245.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
6"
DIE
011
025015
103CS1P
SA-JER-DS011-TRJR-480064
20"
DIE
011
026001
103CS2P
20"-DIE-011018001-101CS2P-H
Reducer
-
SA-JER-DS011-TRJR-480064
2"
DIE
011
026001
103CS2P
20"-DIE-011026001-103CS2P-H
UC
-
SA-JER-DS011-TRJR-380001
Page 67 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
FLUID
THICKNESS (mm)
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480064
3/4"
DIE
011
026001
103CS2P
20"-DIE-011026001-103CS2P-H
011-PI-0214
-
-
H
40
LAGO
Liquid
661
4.10
245.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
16"
DIE
011
026001
103CS2P
Reducer
011-G-0010-A
-
-
H
100
LAGO
Liquid
661
4.10
245.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
20"
DIE
011
026002
103CS2P
20"-DIE-011018001-101CS2P-H
Reducer
-
-
H
100
LAGO
Liquid
661
4.10
245.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
2"
DIE
011
026002
103CS2P
20"-DIE-011026002-103CS2P-H
UC
-
-
H
65
LAGO
Liquid
661
4.10
245.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
3/4"
DIE
011
026002
103CS2P
20"-DIE-011026002-103CS2P-H
011-PI-0217
-
-
H
40
LAGO
Liquid
661
4.10
245.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
16"
DIE
011
026002
103CS2P
Reducer
011-G-0010-B
-
-
H
100
LAGO
Liquid
661
4.10
245.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
12"
DIE
011
026003
103CS2P
011-G-0010-A
Reducer
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
16"
DIE
011
026003
103CS2P
Reducer
16"-DIE-011026003-103CS2P-H
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
3/4"
DIE
011
026003
103CS2P
16"-DIE-011026003-103CS2P-H
16"-DIE-011026003-103CS2P-H
-
-
H
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480064
3/4"
DIE
011
026003
103CS2P
011-PI-0059
16"-DIE-011026003-103CS2P-H
-
-
H
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480018
16"
DIE
011
026003
103CS2P
SA-JER-DS011-TRJR-480064
Reducer
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480018
16"
DIE
011
026003
103CS2P
16"-DIE-011026003-103CS2P-H
Reducer
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480018
3/4"
DIE
011
026003
103CS2P
16"-DIE-011026003-103CS2P-H
011-PDT-0111
-
-
H
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480018
8"
DIE
011
026003
103CS2P
Reducer
8"-DIE-011026003-103CS2P-H
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480018
10"
DIE
011
026003
103CS2P
Reducer
Reducer
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480018
16"
DIE
011
026003
103CS2P
Reducer
16"-DIE-011026003-103CS2P-H
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480018
16"
DIE
011
026003
103CS2P
16"-DIE-011026003-103CS2P-H
Reducer
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480018
16"
DIE
011
026003
103CS2P
Reducer
16"-DIE-011026003-103CS2P-H
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480018
2"
DIE
011
026003
103CS2P
16"-DIE-011026003-103CS2P-H
011-TT-0216
-
-
H
65
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480018
8"
DIE
011
026003
103CS2P
8"-DIE-011026003-103CS2P-H
Reducer
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480018
18"
DIE
011
026003
103CS2P
Reducer
011-E-0013
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
16"
DIE
011
026003
103CS2P
16"-DIE-011026003-103CS2P-H
SA-JER-DS011-TRJR-480018
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
8"
DIE
011
026004
103CS2P
16"-DIE-011026003-103CS2P-H
SA-JER-DS011-TRJR-480044
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
8"
DIE
011
026004
103CS2P
SA-JER-DS011-TRJR-480064
Reducer
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
1/2"
DIE
011
026004
103CS2P
011-FE-0024
011-FT-0024
-
-
H
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
8"
DIE
011
026004
103CS2P
8"-DIE-011026004-103CS2P-H
Reducer
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
1/2"
DIE
011
026004
103CS2P
011-FE-0024
011-FT-0024
-
-
H
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
4"
DIE
011
026004
103CS2P
Reducer
4"-DIE-011018002-101CS2P-H
-
-
H
65
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
6"
DIE
011
026004
103CS2P
Reducer
Reducer
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
NOTE 6
SA-JER-DS011-TRJR-480044
8"
DIE
011
026004
103CS2P
Reducer
8"-DIE-011018002-101CS2P-H
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
12"
DIE
011
026005
103CS2P
011-G-0010-B
Reducer
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
16"
DIE
011
026005
103CS2P
Reducer
16"-DIE-011026005-103CS2P-H
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
3/4"
DIE
011
026005
103CS2P
16"-DIE-011026005-103CS2P-H
16"-DIE-011026005-103CS2P-H
-
-
H
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
3/4"
DIE
011
026005
103CS2P
011-PI-0060
16"-DIE-011026005-103CS2P-H
-
-
H
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
16"
DIE
011
026005
103CS2P
16"-DIE-011026005-103CS2P-H
16"-DIE-011026003-103CS2P-H
-
-
H
100
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
2"
DIE
011
026006
103CS2P
16"-DIE-011026003-103CS2P-H
Insul Brk
-
-
H
65
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
2"
DIE
011
026006
103CS2P
Insul Brk
2"-CLD-011026303-101CH2S-P
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
H
65
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
3/4"
DIE
011
026006
103CS2P
2"-DIE-011026006-103CS2P-P
3/4"-OLW-011026303-101CS1PN
SA-JER-DS011-TRJR-480064
2"
DIE
011
026006
103CS2P
16"-DIE-011026001-103CS2P-H
2"-DIE-011026006-103CS2P-P
2"-DIE-011026006-103CS2P-P
2"-DIE-011026006-103CS2P-P
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
40
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
2"
DIE
011
026006
103CS2P
SA-JER-DS011-TRJR-480064
3/4"
DIE
011
026006
103CS2P
20"-DIE-011026001-103CS2P-H
Insul Brk
-
LAGO
Liquid
SA-JER-DS011-TRJR-480064
3/4"
DIE
011
026006
103CS2P
Insul Brk
2"-DIE-011026006-103CS2P-P
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
3/4"
DIE
011
026006
103CS2P
011-G-0010-A
Reducer
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
1"
DIE
011
026006
103CS2P
Reducer
2"-DIE-011026006-103CS2P-P
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
2"
DIE
011
026007
103CS2P
16"-DIE-011026005-103CS2P-H
Insul Brk
-
-
H
65
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
2"
DIE
011
026007
103CS2P
Insul Brk
2"-CLD-011026304-101CH2S-P
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
3/4"
DIE
011
026007
103CS2P
2"-DIE-011026007-103CS2P-P
3/4"-OLW-011026304-101CS1PN
SA-JER-DS011-TRJR-480064
2"
DIE
011
026007
103CS2P
16"-DIE-011026002-103CS2P-H
2"-DIE-011026007-103CS2P-P
-
-
H
65
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
2"
DIE
011
026007
103CS2P
2"-DIE-011026007-103CS2P-P
2"-DIE-011026007-103CS2P-P
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
3/4"
DIE
011
026007
103CS2P
011-G-0010-B
Reducer
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
1"
DIE
011
026007
103CS2P
Reducer
2"-DIE-011026007-103CS2P-P
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
3/4"
DIE
011
026007
103CS2P
20"-DIE-011026002-103CS2P-H
Insul Brk
-
-
H
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480064
3/4"
DIE
011
026007
103CS2P
Insul Brk
2"-DIE-011026007-103CS2P-P
-
-
P
40
LAGO
Liquid
661
12.70
247.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
14"
DIE
011
030001
101CS1P
011-C-0003
Reducer
-
-
H
50
LVGO
Liquid
801
2.80
141.00
-
-
7.40
-1.00
260.00
260.00
-
H
11.75
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
14"
DIE
011
030001
101CS1P
011-C-0003
Reducer
-
-
H
50
LVGO
Liquid
801
2.80
141.00
-
-
7.40
-1.00
260.00
260.00
-
H
11.75
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
18"
DIE
011
030001
101CS1P
Reducer
SA-JER-DS011-TRJR-480096
-
-
H
65
LVGO
Liquid
801
2.80
141.00
-
-
7.40
-1.00
260.00
260.00
-
H
11.75
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
2"
DIE
011
030001
101CS1P
18"-DIE-011030001-101CS1P-H
011-TT-0199
-
-
H
40
LVGO
Liquid
801
2.80
141.00
-
-
7.40
-1.00
260.00
260.00
-
H
11.75
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
18"
DIE
011
030001
101CS1P
Reducer
18"-DIE-011030001-101CS1P-H
-
-
H
65
LVGO
Liquid
801
2.80
141.00
-
-
7.40
-1.00
260.00
260.00
-
H
11.75
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
18"
DIE
011
030001
101CS1P
SA-JER-DS011-TRJR-480080
18"-DIE-011037001-103CS1P-H
-
-
H
65
LVGO
Liquid
801
2.80
141.00
-
-
7.40
-1.00
260.00
260.00
-
H
11.75
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
18"
DIE
011
030001
101CS1P
18"-DIE-011030001-101CS1P-H
18"-DIE-011037002-103CS1P-H
-
-
H
65
LVGO
Liquid
801
2.80
141.00
-
-
7.40
-1.00
260.00
260.00
-
H
11.75
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
10"
DIE
011
030002
101CS1P
10"-DIE-011037008-103CS1P-P
011-C-0003
-
-
P
25
LVGO
Liquid
854.2
-0.91
60.00
-
-
8.50
-1.00
260.00
260.00
-
H
13.49
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
10"
DIE
011
030002
101CS1P
Reducer
10"-DIE-011030002-101CS1P-P
-
-
P
25
LVGO
Liquid
854.2
-0.91
60.00
-
-
8.50
-1.00
260.00
260.00
-
H
13.49
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
6"
DIE
011
030002
101CS1P
6"-DIE-011037008-103CS1P-P
Reducer
-
-
P
25
LVGO
Liquid
854.2
-0.91
60.00
-
-
8.50
-1.00
260.00
260.00
-
H
13.49
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
3/4"
DIE
011
030002
101CS1P
4"-DIE-011030002-101CS1P-P
Plug
-
-
P
25
LVGO
Liquid
854.2
-0.91
60.00
-
-
8.50
-1.00
260.00
260.00
-
H
13.49
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
4"-FLO-011037301-101CS1P-N
10"-DIE-011030002-101CS1P-P
-
-
P
25
LVGO
Liquid
854.2
-0.91
60.00
-
-
8.50
-1.00
260.00
260.00
-
H
13.49
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
P
25
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
190.00
-
H
31.50
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
4"
DIE
011
030002
101CS1P
SA-JER-DS011-TRJR-480080
3/4"
DIE
011
030003
103CS1P
10"-DIE-011037008-103CS1P-P
Reducer
-
LVGO
Liquid
SA-JER-DS011-TRJR-480080
2"
DIE
011
030003
103CS1P
Reducer
2"-CLD-011030305-101CH2S-N
-
-
P
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
SA-JER-DS011-TRJR-480080
3/4"
DIE
011
030005
101CS1P
011-LG-0043
Reducer
S
8
H
25
LVGO
Liquid
801
-0.90
141.00
-
-
3.50
-1.00
260.00
260.00
-
H
5.56
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
3/4"
DIE
011
030005
101CS1P
3/4"-DIE-011030005-101CS1P-S
Plug
S
8
H
25
LVGO
Liquid
801
-0.90
141.00
-
-
3.50
-1.00
260.00
260.00
-
H
5.56
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
2"
DIE
011
030005
101CS1P
Reducer
2"-CLD-011030301-101CH2S-P
S
8
H
40
LVGO
Liquid
801
-0.90
141.00
-
-
3.50
-1.00
260.00
260.00
-
H
5.56
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
3/4"
DIE
011
030006
101CS1P
011-LG-0043
3/4"-LFL-011030304-101CH2F-N
-
-
P
25
LVGO
Gas
-
-0.90
222.00
-
-
3.50
-1.00
260.00
260.00
-
H
5.56
NFS
By Code
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
3/4"
DIE
011
030006
101CS1P
3/4"-DIE-011030006-101CS1P-P
Plug
-
-
P
25
LVGO
Gas
-
-0.90
222.00
-
-
3.50
-1.00
260.00
260.00
-
H
5.56
NFS
By Code
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
if insulated M or Q SA-JER-DS011-TRJR-480080
-
DIE
011
030601
103CS1P
011-C-0003
TRIM
-
-
H
-
-
-
-
-0.90
80.00
-
-
3.50
-1.00
260.00
260.00
-
Visual Test
0.00
NFS
By Code
SA-JER-DS011-TRJR-480080
2"
DIE
011
030601
103CS1P
011-C-0003
011-LT-0054
S
8
H
25
-
-
-
-0.90
80.00
-
-
3.50
-1.00
260.00
260.00
-
H
5.56
NFS
By Code
SA-JER-DS011-TRJR-480080
2"
DIE
011
030601
103CS1P
011-C-0003
011-PT-0068
S
22
H
25
-
-
-
-0.90
80.00
-
-
3.50
-1.00
260.00
260.00
-
H
5.56
NFS
By Code
SA-JER-DS011-TRJR-480080
2"
DIE
011
030601
103CS1P
011-C-0003
011-LG-0043
S
8
H
25
-
-
-
-0.90
80.00
-
-
3.50
-1.00
260.00
260.00
-
H
5.56
NFS
By Code
SA-JER-DS011-TRJR-480080
2"
DIE
011
030601
103CS1P
011-C-0003
011-LT-0044
S
8
H
25
-
-
-
-0.90
80.00
-
-
3.50
-1.00
260.00
260.00
-
H
5.56
NFS
By Code
SA-JER-DS011-TRJR-380001
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
Page 68 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
011-LT-0054
S
8
H
25
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
-
-
-0.90
80.00
-
-
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
-
H
5.56
NFS
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7) if insulated M or Q
2"
DIE
011
030601
103CS1P
011-C-0003
SA-JER-DS011-TRJR-480096
18"
DIE
011
037001
103CS1P
18"-DIE-011030001-101CS1P-H
Reducer
-
-
H
65
LVGO
Liquid
801
2.80
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037001
103CS1P
18"-DIE-011037001-103CS1P-H
011-PI-0234
-
-
H
25
LVGO
Liquid
801
2.80
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
SA-JER-DS011-TRJR-480096
2"
DIE
011
037001
103CS1P
18"-DIE-011037001-103CS1P-H
UC
-
-
H
40
LVGO
Liquid
801
2.80
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
SA-JER-DS011-TRJR-480096
12"
DIE
011
037001
103CS1P
Reducer
011-G-0015-A
-
-
H
50
LVGO
Liquid
801
2.80
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
SA-JER-DS011-TRJR-480096
18"
DIE
011
037002
103CS1P
18"-DIE-011030001-101CS1P-H
Reducer
-
-
H
65
LVGO
Liquid
801
2.80
141.00
-
-
21.00
190.00
-
H
31.50
NFS
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037002
103CS1P
18"-DIE-011037002-103CS1P-H
011-PI-0235
-
-
H
25
LVGO
Liquid
801
2.80
141.00
-
-
21.00
190.00
-
H
31.50
SA-JER-DS011-TRJR-480096
2"
DIE
011
037002
103CS1P
18"-DIE-011037002-103CS1P-H
UC
-
-
H
40
LVGO
Liquid
801
2.80
141.00
-
-
21.00
190.00
-
H
SA-JER-DS011-TRJR-480096
12"
DIE
011
037002
103CS1P
Reducer
011-G-0015-B
-
-
H
50
LVGO
Liquid
801
2.80
141.00
-
-
21.00
190.00
-
SA-JER-DS011-TRJR-480096
10"
DIE
011
037003
103CS1P
011-G-0015-A
SA-JER-DS011-TRJR-480006
-
-
H
50
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037003
103CS1P
011-PI-0085
10"-DIE-011037003-103CS1P-H
-
-
H
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037003
103CS1P
10"-DIE-011037003-103CS1P-H
10"-DIE-011037003-103CS1P-H
-
-
H
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
SA-JER-DS011-TRJR-480006
10"
DIE
011
037003
103CS1P
SA-JER-DS011-TRJR-480096
Reducer
-
-
H
50
LVGO
Liquid
801
13.30
141.00
-
-
SA-JER-DS011-TRJR-480006
2"
DIE
011
037003
103CS1P
10"-DIE-011037003-103CS1P-H
011-TT-0179
-
-
H
40
LVGO
Liquid
801
13.30
141.00
-
SA-JER-DS011-TRJR-480006
12"
DIE
011
037003
103CS1P
Reducer
011-E-0005
-
-
H
50
LVGO
Liquid
801
13.30
141.00
SA-JER-DS011-TRJR-480006
2"
DIE
011
037003
103CS1P
2"-DIE-011003002-103CS1P-P
10"-DIE-011037003-103CS1P-H
-
-
H
40
LVGO
Liquid
801
13.30
SA-JER-DS011-TRJR-480096
6"
DIE
011
037004
101CS1P
6"-DIE-011037010-103CS1P-H
SA-JER-DS011-TRJR-480080
-
-
H
50
LVGO
Liquid
801
SA-JER-DS011-TRJR-480096
6"
DIE
011
037004
101CS1P
Reducer
6"-DIE-011037004-101CS1P-H
-
-
H
50
LVGO
Liquid
801
SA-JER-DS011-TRJR-480096
3"
DIE
011
037004
101CS1P
3"-DIE-011037010-103CS1P-H
Reducer
-
-
H
40
LVGO
Liquid
SA-JER-DS011-TRJR-480080
6"
DIE
011
037004
101CS1P
SA-JER-DS011-TRJR-480096
011-C-0003
-
-
H
50
LVGO
SA-JER-DS011-TRJR-480097
6"
DIE
011
037005
103CS1P
011-A-0005-A/B
8"-DIE-011037005-103CS1P-P
-
-
P
25
SA-JER-DS011-TRJR-480097
6"
DIE
011
037005
103CS1P
011-A-0005-G/H
8"-DIE-011037005-103CS1P-P
-
-
P
SA-JER-DS011-TRJR-480097
6"
DIE
011
037005
103CS1P
011-A-0005-C/D
8"-DIE-011037005-103CS1P-P
-
-
SA-JER-DS011-TRJR-480097
6"
DIE
011
037005
103CS1P
011-A-0005-G/H
8"-DIE-011037005-103CS1P-P
-
SA-JER-DS011-TRJR-480097
6"
DIE
011
037005
103CS1P
011-A-0005-C/D
8"-DIE-011037005-103CS1P-P
-
SA-JER-DS011-TRJR-480097
6"
DIE
011
037005
103CS1P
011-A-0005-E/F
8"-DIE-011037005-103CS1P-P
SA-JER-DS011-TRJR-480097
6"
DIE
011
037005
103CS1P
011-A-0005-E/F
SA-JER-DS011-TRJR-480097
6"
DIE
011
037005
103CS1P
SA-JER-DS011-TRJR-480097
8"
DIE
011
037005
SA-JER-DS011-TRJR-480097
8"
DIE
011
037005
SA-JER-DS011-TRJR-480080
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
N
POTENTIAL
N
N
N
N
-
NOTE 6
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
4.00
141.00
-
-
7.40
-1.00
260.00
260.00
-
H
11.75
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
4.00
141.00
-
-
7.40
-1.00
260.00
260.00
-
H
11.75
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
801
4.00
141.00
-
-
7.40
-1.00
260.00
260.00
-
H
11.75
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
Liquid
801
4.00
141.00
-
-
7.40
-1.00
260.00
260.00
-
H
11.75
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
P
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
P
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
P
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
8"-DIE-011037005-103CS1P-P
-
-
P
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
011-A-0005-A/B
8"-DIE-011037005-103CS1P-P
-
-
P
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
103CS1P
HEADER
Reducer
-
-
P
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
103CS1P
HEADER
Reducer
-
-
P
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
3.50
-1.00
260.00
260.00
By Code
if NOT insulated B or Q
SA-JER-DS011-TRJR-480098
4"
DIE
011
037005
103CS1P
SA-JER-DS011-TRJR-480097
011-E-0029
-
-
P
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480097
10"
DIE
011
037005
103CS1P
Reducer
Reducer
-
-
P
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480097
10"
DIE
011
037005
103CS1P
Reducer
10"-DIE-011037005-103CS1P-P
-
-
P
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480097
4"
DIE
011
037005
103CS1P
Reducer
SA-JER-DS011-TRJR-480098
-
-
P
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480098
6"
DIE
011
037006
103CS1P
6"-DIE-011037007-103CS1P-N
SA-JER-DS011-TRJR-480138
-
-
N
-
LVGO
Liquid
862.5
7.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
6"
DIE
011
037006
103CS1P
SA-JER-DS011-TRJR-480138
Insul Brk
-
-
N
-
LVGO
Liquid
862.5
7.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
6"
DIE
011
037006
103CS1P
Insul Brk
8"-SLP-011098003-103CS1P-S
S
41
H
40
LVGO
Liquid
846
6.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480138
6"
DIE
011
037006
103CS1P
SA-JER-DS011-TRJR-480098
SA-JER-DS011-TRJR-480136
-
-
N
-
LVGO
Liquid
862.5
7.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6 MAX. TEMPERATURE FOR OTHER CASES: 50ºC. NOTE 6 MAX. TEMPERATURE FOR OTHER RELIEF CASES: 50ºC.NOTE 6 MAX. TEMPERATURE FOR OTHER RELIEF CASES: 50ºC.NOTE 6 MAX. TEMPERATURE FOR OTHER CASES: 50ºC. NOTE 6 MAX. TEMPERATURE FOR OTHER CASES: 50ºC. NOTE 6 MAX. TEMPERATURE FOR OTHER RELIEF CASES: 50ºC.NOTE 6 MAX. TEMPERATURE FOR OTHER RELIEF CASES: 50ºC.NOTE 6 MAX. TEMPERATURE FOR OTHER RELIEF CASES: 50ºC.NOTE 6
SA-JER-DS011-TRJR-480098
4"
DIE
011
037007
103CS1P
011-E-0029
Reducer
-
-
N
-
LVGO
Liquid
862.5
11.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480098
6"
DIE
011
037007
103CS1P
Reducer
Reducer
-
-
N
-
LVGO
Liquid
862.5
11.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480132
6"
DIE
011
037007
103CS1P
SA-JER-DS011-TRJR-480098
6"-DIE-011037007-103CS1P-N
-
-
N
-
LVGO
Liquid
862.5
7.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480132
6"
DIE
011
037007
103CS1P
6"-DIE-011037007-103CS1P-N
8"-DIE-011025003-103CS1P-N
-
-
N
-
LVGO
Liquid
862.5
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480098
3"
DIE
011
037007
103CS1P
Reducer
Reducer
-
-
N
-
LVGO
Liquid
862.5
11.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480098
6"
DIE
011
037007
103CS1P
Reducer
6"-DIE-011037007-103CS1P-N
-
-
N
-
LVGO
Liquid
862.5
11.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480098
6"
DIE
011
037007
103CS1P
6"-DIE-011037007-103CS1P-N
SA-JER-DS011-TRJR-480132
-
-
N
-
LVGO
Liquid
862.5
7.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480097
10"
DIE
011
037008
103CS1P
10"-DIE-011037005-103CS1P-P
SA-JER-DS011-TRJR-480080
-
-
P
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
10"
DIE
011
037008
103CS1P
SA-JER-DS011-TRJR-480097
Reducer
-
-
P
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
1/2"
DIE
011
037008
103CS1P
011-FE-0038
011-FT-0038
-
-
P
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
6"
DIE
011
037008
103CS1P
Reducer
6"-DIE-011030002-101CS1P-P
-
-
P
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
1/2"
DIE
011
037008
103CS1P
011-FE-0038
011-FT-0038
-
-
P
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
10"
DIE
011
037008
103CS1P
10"-DIE-011037008-103CS1P-P
Reducer
-
-
P
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
8"
DIE
011
037008
103CS1P
Reducer
Reducer
-
-
P
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
10"
DIE
011
037008
103CS1P
Reducer
10"-DIE-011030002-101CS1P-P
-
-
P
25
LVGO
Liquid
854.2
10.60
60.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
10"
DIE
011
037009
103CS1P
011-G-0015-B
Reducer
-
-
H
50
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
10"
DIE
011
037009
103CS1P
Reducer
10"-DIE-011037003-103CS1P-H
-
-
H
50
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037009
103CS1P
10"-DIE-011037009-103CS1P-H
10"-DIE-011037009-103CS1P-H
-
-
H
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037009
103CS1P
10"-DIE-011037009-103CS1P-H
011-PI-0086
-
-
H
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
6"
DIE
011
037010
103CS1P
10"-DIE-011037003-103CS1P-H
Reducer
-
-
H
50
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
1/2"
DIE
011
037010
103CS1P
011-FT-0046
011-FE-0046
-
-
H
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
3"
DIE
011
037010
103CS1P
Reducer
3"-DIE-011037004-101CS1P-H
-
-
H
40
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
6"
DIE
011
037010
103CS1P
6"-DIE-011037010-103CS1P-H
Reducer
-
-
H
50
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
1/2"
DIE
011
037010
103CS1P
011-FT-0046
011-FE-0046
-
-
H
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
4"
DIE
011
037010
103CS1P
Reducer
Reducer
-
-
H
50
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
6"
DIE
011
037010
103CS1P
Reducer
6"-DIE-011037004-101CS1P-H
-
-
H
50
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
2"
DIE
011
037011
103CS1P
10"-DIE-011037003-103CS1P-H
Insul Brk
-
-
H
40
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
1/2"
DIE
011
037011
103CS1P
011-PI-0085
2"-DIE-011037011-103CS1P-P
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
2"
DIE
011
037011
103CS1P
Insul Brk
2"-CLD-011037301-101CH2S-P
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037011
103CS1P
2"-DIE-011037011-103CS1P-P
3/4"-OLW-011037301-101CS1PN
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037011
103CS1P
18"-DIE-011037001-103CS1P-H
Insul Brk
-
-
H
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037011
103CS1P
Insul Brk
2"-DIE-011037011-103CS1P-P
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
2"
DIE
011
037011
103CS1P
12"-DIE-011037001-103CS1P-H
2"-DIE-011037011-103CS1P-P
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037011
103CS1P
011-G-0015-A
2"-DIE-011037011-103CS1P-P
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037011
103CS1P
011-G-0015-A
2"-DIE-011037011-103CS1P-P
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037011
103CS1P
011-G-0015-A
2"-DIE-011037011-103CS1P-P
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037011
103CS1P
011-G-0015-A
2"-DIE-011037011-103CS1P-P
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
2"
DIE
011
037012
103CS1P
10"-DIE-011037009-103CS1P-H
Insul Brk
-
-
H
40
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
1/2"
DIE
011
037012
103CS1P
011-PI-0086
2"-DIE-011037012-103CS1P-P
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
2"
DIE
011
037012
103CS1P
Insul Brk
2"-CLD-011037302-101CH2S-P
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037012
103CS1P
2"-DIE-011037012-103CS1P-P
3/4"-OLW-011037302-101CS1PN
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037012
103CS1P
18"-DIE-011037002-103CS1P-H
Insul Brk
-
-
H
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037012
103CS1P
Insul Brk
2"-DIE-011037012-103CS1P-P
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
2"
DIE
011
037012
103CS1P
12"-DIE-011037002-103CS1P-H
2"-DIE-011037012-103CS1P-P
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037012
103CS1P
011-G-0015-B
2"-DIE-011037012-103CS1P-P
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037012
103CS1P
011-G-0015-B
2"-DIE-011037012-103CS1P-P
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037012
103CS1P
011-G-0015-B
2"-DIE-011037012-103CS1P-P
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037012
103CS1P
011-G-0015-B
2"-DIE-011037012-103CS1P-P
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 69 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
INSULATION (NOTE 2)
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037013
103CS1P
6"-DIE-011037010-103CS1P-H
Insul Brk
-
-
H
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037013
103CS1P
Insul Brk
Reducer
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037013
103CS1P
3/4"-DIE-011037013-103CS1P-P
Plug
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
2"
DIE
011
037013
103CS1P
Reducer
2"-CLD-011037303-101CH2S-P
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037013
103CS1P
6"-DIE-011037010-103CS1P-H
Insul Brk
-
-
H
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480096
3/4"
DIE
011
037013
103CS1P
Insul Brk
3/4"-DIE-011037013-103CS1P-P
-
-
P
25
LVGO
Liquid
801
13.30
141.00
-
-
21.00
190.00
-
H
31.50
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480098
3/4"
DIE
011
037014
103CS1P
6"-DIE-011037007-103CS1P-N
011-SC-0002
-
-
N
-
LVGO
Liquid
862.5
11.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480098
3/4"
DIE
011
037015
103CS1P
011-SC-0002
6"-DIE-011037007-103CS1P-N
-
-
N
-
LVGO
Liquid
862.5
7.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6 MAX. TEMPERATURE FOR OTHER CASES: 50ºC. NOTE 6, 10
SA-JER-DS011-TRJR-480098
4"
DIE
011
037016
103CS1P
6"-DIE-011037007-103CS1P-N
011-SP-0033
-
-
N
-
LVGO
Liquid
862.5
11.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480098
4"
DIE
011
037016
103CS1P
011-SP-0033
Reducer
-
-
N
-
LVGO
Liquid
862.5
11.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480098
1-1/2"
DIE
011
037016
103CS1P
Reducer
011-PZV-0069-B
-
-
N
-
LVGO
Liquid
862.5
11.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CAUSES: 50ºC MAX. TEMPERATURE FOR OTHER CAUSES: 50ºC. NOTE 6, 10
SA-JER-DS011-TRJR-480098
4"
DIE
011
037016
103CS1P
4"-DIE-011037016-103CS1P-N
011-SP-0033
-
-
N
-
LVGO
Liquid
862.5
11.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CAUSES: 50ºC
SA-JER-DS011-TRJR-480098
4"
DIE
011
037016
103CS1P
011-SP-0033
Reducer
-
-
N
-
LVGO
Liquid
862.5
11.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480098
1-1/2"
DIE
011
037016
103CS1P
Reducer
011-PZV-0069-A
-
-
N
-
LVGO
Liquid
862.5
11.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CAUSES: 50ºC
4"-LFL-011037301-101CH2F-N
-
-
N
-
LVGO
Liquid
862.5
11.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
6"-DIE-011037007-103CS1P-N
Reducer
-
-
N
-
LVGO
Liquid
862.5
11.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
Reducer
2"-CLD-011037004-101CH2S-P
-
-
N
-
LVGO
Liquid
862.5
11.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
6"-DIE-011037007-103CS1P-N
3/4"-DIE-011037017-103CS1P-N
-
-
N
-
LVGO
Liquid
862.5
11.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480098
2"
DIE
011
037016
103CS1P
4"-DIE-011037016-103CS1P-N
SA-JER-DS011-TRJR-480098
3/4"
DIE
011
037017
103CS1P
SA-JER-DS011-TRJR-480098
2"
DIE
011
037017
103CS1P
SA-JER-DS011-TRJR-480098
3/4"
DIE
011
037017
103CS1P
SA-JER-DS011-TRJR-480098
3/4"
DIE
011
037020
103CS1P
SA-JER-DS011-TRJR-480098
2"
DIE
011
037020
SA-JER-DS011-TRJR-480097
2"
DIE
011
037021
SA-JER-DS011-TRJR-480097
3/4"
DIE
011
SA-JER-DS011-TRJR-480097
1-1/2"
DIE
SA-JER-DS011-TRJR-480097
2"
DIE
MAX. TEMPERATURE FOR OTHER CAUSES: 50ºC
MAX. TEMPERATURE FOR OTHER CAUSES: 50ºC. NOTE 6, 10
6"-DIE-011037007-103CS1P-N
Reducer
-
-
N
-
LVGO
Liquid
862.5
103CS1P
Reducer
2"-CLD-011037309-101CH2S-P
-
-
103CS1P
10"-DIE-011003001-103CS1P-P
2"-LFL-011037302-101CH2F-N
-
-
037021
103CS1P
2"-DIE-011037021-103CS1P-P
Plug
-
011
037023
103CS1P
011-A-0005-A/B
Reducer
011
037023
103CS1P
Reducer
11.50
50.00
-
-
21.00
80.00
-
H
31.50
N
-
LVGO
Liquid
862.5
11.50
50.00
-
-
21.00
80.00
-
H
31.50
P
25
LVGO
Gas
-
13.17
126.50
-
-
21.00
190.00
-
H
31.50
-
P
25
LVGO
Gas
-
13.17
126.50
-
-
21.00
190.00
-
H
31.50
-
-
N
-
LVGO
Liquid
854
10.60
60.00
-
-
21.00
190.00
-
H
2"-CLD-011037308-101CH2S-P
-
-
N
-
LVGO
Liquid
854
10.60
60.00
-
-
21.00
190.00
-
-
-
N
-
LVGO
Liquid
854
10.60
60.00
-
-
21.00
190.00
NFS
NOTE 6 NOTE 6 NOTE 6. UP TO GATE VALVE ITEM 15 IN ISOMETRIC LGO011037020/01 TEST PRESSURE SHOULD BE 42,45BARG NOTE 6. UP TO GATE VALVE ITEM 15 IN ISOMETRIC LGO011037020/01 TEST PRESSURE SHOULD BE 42,45BARG
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
31.50
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
H
31.50
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
31.50
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480097
3/4"
DIE
011
037023
103CS1P
2"-DIE-011037023-103CS1P-N
3/4"-OLW-011037303-101CS1PN
SA-JER-DS011-TRJR-480110
8"
DIE
011
043001
103CS1P
011-E-0024
Reducer
-
-
P
25
LAGO
Liquid
787.3
12.60
85.50
-
-
20.00
140.00
-
H
30.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480110
6"
DIE
011
043001
103CS1P
Reducer
SA-JER-DS011-TRJR-480059
-
-
P
25
LAGO
Liquid
787.3
12.60
85.50
-
-
20.00
140.00
-
H
30.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480059
6"
DIE
011
043001
103CS1P
SA-JER-DS011-TRJR-480110
011-A-0003-A/B
-
-
P
25
LAGO
Liquid
787.3
12.60
85.50
-
-
20.00
140.00
-
H
30.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480059
3/4"
DIE
011
043001
103CS1P
6"-DIE-011043001-103CS1P-P
UC
-
-
P
25
LAGO
Liquid
787.3
12.60
85.50
-
-
20.00
140.00
-
H
30.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480059
6"
DIE
011
043001
103CS1P
6"-DIE-011043001-103CS1P-P
011-A-0003-A/B
-
-
P
25
LAGO
Liquid
787.3
12.60
85.50
-
-
20.00
140.00
-
H
30.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480110
3/4"
DIE
011
043002
103CS1P
6"-DIE-011043001-103CS1P-P
Reducer
-
-
P
25
LAGO
Liquid
787.3
12.60
85.50
-
-
20.00
140.00
-
H
30.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480110
3/4"
DIE
011
043002
103CS1P
3/4"-DIE-011043002-103CS1P-P
Plug
-
-
P
25
LAGO
Liquid
787.3
12.60
85.50
-
-
20.00
140.00
-
H
30.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480110
2"
DIE
011
043002
103CS1P
Reducer
2"-CLD-011043301-101CH2S-P
-
-
P
25
LAGO
Liquid
787.3
12.60
85.50
-
-
20.00
140.00
-
H
30.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
16"
DIE
011
098001
103CS1P
SA-JER-DS111-TRJR-480042
SA-JER-DS011-TRJR-480043
-
-
H
100
LAGO
Liquid
708
8.10
201.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
3/4"
DIE
011
098001
103CS1P
16"-DIE-011098001-103CS1P-H
011-PT-0426
-
-
H
40
LAGO
Liquid
708
8.10
201.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
3/4"
DIE
011
098001
103CS1P
16"-DIE-011098001-103CS1P-H
011-PI-0169
-
-
H
40
LAGO
Liquid
708
8.10
201.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
14"
DIE
011
098001
103CS1P
16"-DIE-011098001-103CS1P-H
Reducer
-
-
H
65
LAGO
Liquid
708
8.10
201.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
10"
DIE
011
098001
103CS1P
Reducer
10"-DIE-011018003-101CS1P-H
-
-
H
65
LAGO
Liquid
708
8.10
201.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
1/2"
DIE
011
098001
103CS1P
011-FE-0023
011-FT-0023
-
-
H
40
LAGO
Liquid
708
8.10
201.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
1/2"
DIE
011
098001
103CS1P
011-FE-0023
011-FT-0023
-
-
H
40
LAGO
Liquid
708
8.10
201.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
12"
DIE
011
098001
103CS1P
Reducer
Reducer
-
-
H
65
LAGO
Liquid
708
8.10
201.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
16"
DIE
011
098001
103CS1P
Reducer
16"-DIE-011018003-101CS1P-H
-
-
H
100
LAGO
Liquid
708
8.10
201.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
16"
DIE
011
098001
103CS1P
SA-JER-DS011-TRJR-480140
Reducer
-
-
H
100
LAGO
Liquid
708
8.10
201.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480133
6"
DIE
011
098002
103CS1P
6"-DIE-011025015-103CS1P-N
6"-DIE-011098002-103CS1P-N
-
-
N
-
LAGO
Liquid
854
7.00
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480133
6"
DIE
011
098002
103CS1P
6"-DIE-011098002-103CS1P-N
SA-JER-DS011-TRJR-480132
-
-
N
-
LAGO
Liquid
854
7.53
50.00
-
170.00
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
6"
DIE
011
098002
103CS1P
SA-JER-DS011-TRJR-480133
6"-DIE-011025003-103CS1P-N
-
-
N
-
LVGO
Liquid
854
7.53
50.00
-
170.00
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3/4"
DIE
011
098003
103CS1P
6"-DIE-011037007-103CS1P-N
Reducer
-
-
N
-
LVGO
Liquid
863
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
2"
DIE
011
098003
103CS1P
Reducer
2"-CLD-011098317-101CH2S-P
-
-
N
-
LVGO
Liquid
863
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3/4"
DIE
011
098003
103CS1P
6"-DIE-011037007-103CS1P-N
3/4"-DIE-011098003-103CS1P-N
-
-
N
-
LVGO
Liquid
863
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480133
3/4"
DIE
011
098004
103CS1P
6"-DIE-011025002-103CS1P-N
Reducer
-
-
N
-
LAGO
Liquid
854
7.00
50.00
-
-
23.30
80.00
-
H
34.95
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480133
2"
DIE
011
098004
103CS1P
Reducer
2"-CLD-011098307-101CH2S-P
-
-
N
-
LAGO
Liquid
854
7.00
50.00
-
-
23.30
80.00
-
H
34.95
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480133
3/4"
DIE
011
098004
103CS1P
6"-DIE-011025002-103CS1P-N
3/4"-DIE-011098004-103CS1P-N
-
-
N
-
LAGO
Liquid
854
7.00
50.00
-
-
23.30
80.00
-
H
34.95
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480133
3/4"
DIE
011
098005
103CS1P
6"-DIE-011025015-103CS1P-N
Reducer
-
-
N
-
LAGO
Liquid
854
7.00
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480133
2"
DIE
011
098005
103CS1P
Reducer
2"-CLD-011098306-101CH2S-P
-
-
N
-
LAGO
Liquid
854
7.00
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480133
3/4"
DIE
011
098005
103CS1P
6"-DIE-011025015-103CS1P-N
3/4"-DIE-011098005-103CS1P-N
-
-
N
-
LAGO
Liquid
854
7.00
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
8"
DIE
011
098006
103CS1P
8"-DIE-011025003-103CS1P-N
Reducer
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3/4"
DIE
011
098006
103CS1P
10"-DIE-011098006-103CS1P-H
011-PI-0493
-
-
N
-
HAGO
Liquid
853
7.00
50.00
-
-
28.30
118.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
6"
DIE
011
098006
103CS1P
Reducer
Reducer
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
8"
DIE
011
098006
103CS1P
8"-DIE-011098006-103CS1P-N
Insul Brk
-
-
N
-
HAGO
Liquid
875
7.00
50.00
-
-
28.30
118.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
8"
DIE
011
098006
103CS1P
Insul Brk
Reducer
-
-
H
40
HAGO
Liquid
875
7.00
50.00
-
-
28.30
118.00
-
H
42.45
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
10"
DIE
011
098006
103CS1P
Reducer
IP-1316-L
-
-
H
40
HAGO
Liquid
875
7.00
50.00
-
-
28.30
118.00
-
H
42.45
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
2"
DIE
011
098006
103CS1P
10"-DIE-011098006-103CS1P-H
Blind flange
-
-
H
25
HAGO
Liquid
875
7.00
50.00
-
-
28.30
118.00
-
H
42.45
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
8"
DIE
011
098006
103CS1P
Reducer
8"-DIE-011098006-103CS1P-N
-
-
N
-
HAGO
Liquid
875
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
2"
DIE
011
098007
103CS1P
16"-DIE-011098001-103CS1P-H
Insul Brk
-
-
H
50
LAGO
Liquid
708
8.10
201.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
2"
DIE
011
098007
103CS1P
Insul Brk
2"-CLD-011098308-101CH2S-P
-
-
P
25
LAGO
Liquid
708
8.10
201.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
2"
DIE
011
098007
103CS1P
2"-DIE-011098007-103CS1P-P
Blind flange
-
-
P
25
LAGO
Liquid
708
8.10
201.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
2"
DIE
011
098007
103CS1P
Insul Brk
2"-DIE-011098007-103CS1P-P
-
-
P
25
LAGO
Liquid
708
8.10
201.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
2"
DIE
011
098007
103CS1P
16"-DIE-011098001-103CS1P-H
Insul Brk
-
-
H
50
LAGO
Liquid
708
8.10
201.00
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
16"
DIE
011
098008
103CS1P
16"-DIE-011010001-103CS1P-H
Reducer
-
-
H
100
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
3/4"
DIE
011
098008
103CS1P
16"-DIE-011098008-103CS1P-H
011-PDT-0385
-
-
H
40
LAGO
Liquid
675
8.10
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
8"
DIE
011
098008
103CS1P
Reducer
8"-DIE-011098008-103CS1P-H
-
-
H
65
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
3/4"
DIE
011
098008
103CS1P
16"-DIE-011098008-103CS1P-H
011-PDT-0385
-
-
H
40
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
16"
DIE
011
098008
103CS1P
16"-DIE-011098008-103CS1P-H
Reducer
-
-
H
100
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
10"
DIE
011
098008
103CS1P
Reducer
Reducer
-
-
H
65
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
16"
DIE
011
098008
103CS1P
Reducer
16"-DIE-011098008-103CS1P-H
-
-
H
100
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
8"
DIE
011
098008
103CS1P
8"-DIE-011098008-103CS1P-H
Reducer
-
-
H
65
LAGO
Liquid
675
8.10
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
16"
DIE
011
098008
103CS1P
Reducer
16"-DIE-011098008-103CS1P-H
-
-
H
100
LAGO
Liquid
675
8.10
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
16"
DIE
011
098008
103CS1P
16"-DIE-011098008-103CS1P-H
16"-DIE-011098001-103CS1P-H
-
-
H
100
LAGO
Liquid
675
8.10
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480133
6"
DIE
011
098009
103CS1P
6"-DIE-011025002-103CS1P-N
SA-JER-DS011-TRJR-480136
-
-
N
-
LAGO
Liquid
809.6
7.00
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
6"
DIE
011
098009
103CS1P
SA-JER-DS011-TRJR-480133
6"-SLP-011099001-103CS1P-S
-
-
N
-
LAGO
Liquid
809.6
7.00
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
6"
DIE
011
098010
103CS1P
6"-DIE-011098009-103CS1P-N
Insul Brk
-
-
N
-
LAGO
Liquid
846
7.00
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
6"
DIE
011
098010
103CS1P
Insul Brk
6"-DIE-011098010-103CS1P-S
S
41
H
40
LAGO
Liquid
846
7.00
50.00
-
-
20.00
155.00
-
H
30.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
6"
DIE
011
098010
103CS1P
6"-DIE-011098010-103CS1P-S
8"-HFO-011098012-103CS1P-S
S
41
H
40
LAGO
Liquid
846
6.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
3/4"
DIE
011
098011
103CS1P
16"-DIE-011098008-103CS1P-H
Insul Brk
-
-
H
40
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
3/4"
DIE
011
098011
103CS1P
Insul Brk
Reducer
-
-
P
25
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
3/4"
DIE
011
098011
103CS1P
3/4"-DIE-011098011-103CS1P-P
Plug
-
-
P
25
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
2"
DIE
011
098011
103CS1P
Reducer
2"-CLD-011098322-101CH2S-P
-
-
P
40
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
2"
DIE
011
098012
103CS1P
16"-DIE-011010001-103CS1P-H
Insul Brk
-
-
H
50
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
2"
DIE
011
098012
103CS1P
Insul Brk
2"-CLD-011098309-101CH2S-P
-
-
P
40
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
2"
DIE
011
098012
103CS1P
2"-DIE-011098012-103CS1P-P
Blind flange
-
-
P
40
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 70 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9) DIE
011
NUMBER 098012
LINE CLASS 103CS1P
FROM
TO
TYPE
TEMP. (ºC)
INSULATION (NOTE 2)
TYPE
THICKNESS (mm)
FLUID
PHASE
(NOTE 3)
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
Insul Brk
2"-DIE-011098012-103CS1P-P
-
-
P
40
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
2"
DIE
011
098012
103CS1P
16"-DIE-011010001-103CS1P-H
Insul Brk
-
-
H
50
LAGO
Liquid
675
11.00
229.40
-
-
17.00
275.00
-
H
27.62
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
DIE
011
200001
103CS1P
3/4"-DIE-011037015-103CS1P-N
Reducer
-
-
N
-
LVGO
Liquid
862.5
7.50
50.00
-
-
21.00
80.00
-
H
31.50
NFS
By Code
A or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
2"
DIE
011
200001
103CS1P
Reducer
2"-CLD-011200301-101CH2S-P
-
-
N
-
LVGO
Liquid
862.5
7.50
50.00
-
-
21.00
80.00
-
H
31.50
NFS
By Code
A or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
DIE
011
200002
103CS1P
3/4"-DIE-011025007-103CS1P-N
Reducer
-
-
N
-
LAGO
Liquid
854
7.00
50.00
-
-
20.00
-0.50
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
2"
DIE
011
200002
103CS1P
Reducer
2"-CLD-011200302-101CH2S-P
-
-
N
-
LAGO
Liquid
854
7.00
50.00
-
-
20.00
-0.50
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480289
1"
DIE
011
230001
101CS1P
Blind flange
Reducer
-
-
N
-
LVGO
Liquid
862.5
0.50
50.00
-
-
3.50
200.00
-
H
5.25
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480289
2"
DIE
011
230001
101CS1P
Reducer
2"-CLD-011230301-101CH2S-N
-
-
N
-
LVGO
Liquid
862.5
0.50
50.00
-
-
3.50
200.00
-
H
5.25
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
N
-
LVGO
Liquid
862.5
0.50
50.00
-
-
3.50
200.00
-
H
5.25
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
2"
UNIT
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
DOC. No.
SA-JER-DS011-TRJR-480289
3/4"
DIE
011
230001
101CS1P
1"-DIE-011230001-101CS1P-N
3/4"-OLW-011230301-101CS1PN
SA-JER-DS011-TRJR-480205
2"
DWA
011
034302
101SR0P
2"-DWA-011079301-101SR0P-N
SA-JER-DS011-TRJR-480089
-
-
N
-
DEMINERALIZED WATER
Liquid
994
3.00
35.00
-
-
11.00
-1.00
80.00
100.00
-
H
16.50
NFS
NO
E
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480089
2"
DWA
011
034302
101SR0P
SA-JER-DS011-TRJR-480205
2"-DWA-011034302-101SR0P-N
-
-
N
-
DEMINERALIZED WATER
Liquid
994
3.00
35.00
-
-
11.00
-1.00
80.00
100.00
-
H
16.50
NFS
NO
E
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480089
2"
DWA
011
034302
101SR0P
2"-DWA-011034302-101SR0P-N
011-D-0009
-
-
N
-
DEMINERALIZED WATER
Liquid
994
3.00
35.00
-
-
11.00
-1.00
80.00
100.00
-
H
16.50
NFS
NO
E
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480206
1-1/2"
DWA
011
054301
101SR0P
2"-DWA-011071302-101SR0P-N
SA-JER-DS011-TRJR-480128
-
-
N
-
DEMINERALIZED WATER
Liquid
994
3.00
35.00
-
-
11.00
80.00
-
H
16.50
NFS
NO
E
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480128
1-1/2"
DWA
011
054301
101SR0P
SA-JER-DS011-TRJR-480206
1-1/2"-DWA-011054401-101SR0PN
-
-
N
-
DEMINERALIZED WATER
Liquid
994
3.00
35.00
-
-
11.00
80.00
-
H
16.50
NFS
NO
E
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480128
1-1/2"
DWA
011
054401
101SR0P
1-1/2"-DWA-011054301101SR0P-N
Reducer
-
-
N
-
DEMINERALIZED WATER
Liquid
994
3.00
35.00
-
-
11.00
80.00
-
H
16.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480128
2"
DWA
011
054401
101SR0P
Reducer
011-D-0034
-
-
N
-
DEMINERALIZED WATER
Liquid
994
3.00
35.00
-
-
11.00
80.00
-
H
16.50
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480202
2"
DWA
011
071302
101SR0P
IP-1325 L
SA-JER-DS011-TRJR-480206
-
-
N
-
DEMINERALIZED WATER
Liquid
994
3.00
35.00
-
-
11.00
80.00
-
H
16.50
NFS
NO
E
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
2"
DWA
011
071302
101SR0P
2"-DWA-011071302-101SR0P-N
SA-JER-DS011-TRJR-480204
-
-
N
-
DEMINERALIZED WATER
Liquid
994
3.00
35.00
-
-
11.00
80.00
-
H
16.50
NFS
NO
E
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480206
2"
DWA
011
071302
101SR0P
SA-JER-DS011-TRJR-480202
HEADER
-
-
N
-
DEMINERALIZED WATER
Liquid
994
3.00
35.00
-
-
11.00
80.00
-
H
16.50
NFS
NO
E
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480204
2"
DWA
011
071302
101SR0P
SA-JER-DS011-TRJR-480202
SA-JER-DS011-TRJR-480313
-
-
N
-
DEMINERALIZED WATER
Liquid
994
3.00
35.00
-
-
11.00
80.00
-
H
16.50
NFS
NO
E
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480313
2"
DWA
011
071302
101SR0P
SA-JER-DS011-TRJR-480204
SA-JER-DS011-TRJR-480205
-
-
N
-
DEMINERALIZED WATER
Liquid
994
3.00
35.00
-
-
11.00
80.00
-
H
16.50
NFS
NO
E
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480205
2"
DWA
011
071302
101SR0P
SA-JER-DS011-TRJR-480313
SA-JER-DS011-TRJR-480203
-
-
N
-
DEMINERALIZED WATER
Liquid
994
3.00
35.00
-
-
11.00
80.00
-
H
16.50
NFS
NO
E
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480203
2"
DWA
011
071302
101SR0P
SA-JER-DS011-TRJR-480205
HEADER
-
-
N
-
DEMINERALIZED WATER
Liquid
994
3.00
35.00
-
-
11.00
80.00
-
H
16.50
NFS
NO
E
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480205
2"
DWA
011
079301
101SR0P
2"-DWA-011071302-101SR0P-N
SA-JER-DS011-TRJR-480233
-
-
N
-
DEMINERALIZED WATER
Liquid
994
3.00
35.00
-
-
11.00
80.00
-
H
16.50
NFS
NO
E
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480233
2"
DWA
011
079301
101SR0P
SA-JER-DS011-TRJR-480205
2"-AMD-011079315-101CH2S-P
-
-
N
-
DEMINERALIZED WATER
Liquid
994
3.00
35.00
-
-
11.00
80.00
-
H
16.50
NFS
NO
E
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480215
3"
FGS
011
019301
101CS2P
12"-FGS-011075302-101CS2P-S
SA-JER-DS011-TRJR-480046
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3"
FGS
011
019301
101CS2P
SA-JER-DS011-TRJR-480215
3"-NAP-011019005-101CH2S-S
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480215
3"
FGS
011
021301
101CS2P
12"-FGS-011075302-101CS2P-S
SA-JER-DS011-TRJR-480050
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
3"
FGS
011
021301
101CS2P
SA-JER-DS011-TRJR-480215
3"-NAP-011021004-101CH2S-S
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480215
2"
FGS
011
034301
101CS2P
12"-FGS-011075302-101CS2P-S
SA-JER-DS011-TRJR-480090
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480090
2"
FGS
011
034301
101CS2P
SA-JER-DS011-TRJR-480215
2"-GAS-011034015-101CH4S-S
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480090
3/4"
FGS
011
034301
101CS2P
2"-FGS-011034301-101CS2P-S
011-PI-0457
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6 NOTE 6
-
SA-JER-DS011-TRJR-480090
1"
FGS
011
034301
101CS2P
2"-FGS-011034301-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480115
3/4"
FGS
011
045002
101CS2P
011-ZV-0035
Reducer
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
55.00
-
H
0.00
NFS
By Code
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
2"
FGS
011
045002
101CS2P
Reducer
ATM
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
55.00
-
Visual Test
0.00
NFS
By Code
A or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480215
8"
FGS
011
045302
101CS2P
12"-FGS-011075302-101CS2P-S
SA-JER-DS011-TRJR-480115
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480115
8"
FGS
011
045302
101CS2P
SA-JER-DS011-TRJR-480215
Reducer
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
FGS
011
045302
101CS2P
8"-FGS-011045302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
FGS
011
045302
101CS2P
8"-FGS-011045302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
FGS
011
045302
101CS2P
8"-FGS-011045302-101CS2P-S
011-PDT-0143
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
1/2"
FGS
011
045302
101CS2P
011-FE-0069
011-FT-0069-A
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
1/2"
FGS
011
045302
101CS2P
011-FE-0069
011-FT-0069-A
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
FGS
011
045302
101CS2P
8"-FGS-011045302-101CS2P-S
011-PDT-0143
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
8"
FGS
011
045302
101CS2P
8"-FGS-011045302-101CS2P-S
8"-FGS-011045302-101CS2P-S
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
6"
FGS
011
045302
101CS2P
Reducer
Reducer
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
8"
FGS
011
045302
101CS2P
Reducer
HEADER
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
FGS
011
045302
101CS2P
8"-FGS-011045302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
FGS
011
045302
101CS2P
8"-FGS-011045302-101CS2P-S
011-PI-0130
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
FGS
011
045302
101CS2P
8"-FGS-011045302-101CS2P-S
011-PT-0386
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
FGS
011
045302
101CS2P
8"-FGS-011045302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
2"
FGS
011
045302
101CS2P
8"-FGS-011045302-101CS2P-S
011-F-0001
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
FGS
011
045302
101CS2P
8"-FGS-011045302-101CS2P-S
011-PI-0131
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
FGS
011
045302
101CS2P
8"-FGS-011045302-101CS2P-S
011-PT-0136
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
8"-FGS-011045302-101CS2P-S
011-F-0001
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
36.8
H
25
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
2"
FGS
011
045302
101CS2P
SA-JER-DS011-TRJR-480115
3/4"
FGS
011
045302
101CS2P
8"-FGS-011045302-101CS2P-S
Plug
S
FUEL GAS
Gas
SA-JER-DS011-TRJR-480115
3/4"
FGS
011
045302
101CS2P
8"-FGS-011045302-101CS2P-S
011-ZV-0035
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
2"
FGS
011
045302
101CS2P
8"-FGS-011045302-101CS2P-S
011-F-0001
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
FGS
011
045302
101CS2P
2"-FGS-011045302-101CS2P-S
011-PI-0126
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3"
FGS
011
045302
101CS2P
8"-FGS-011045302-101CS2P-S
Reducer
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
FGS
011
045302
101CS2P
3"-FGS-011045302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
2"
FGS
011
045302
101CS2P
Reducer
Reducer
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3"
FGS
011
045302
101CS2P
Reducer
8"-FGS-011045302-101CS2P-S
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
FGS
011
045302
101CS2P
3"-FGS-011045302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
2"
FGS
011
046002
101CS2P
Reducer
ATM
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
55.00
-
Visual Test
0.00
NFS
By Code
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
FGS
011
046002
101CS2P
011-ZV-0055
Reducer
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
55.00
-
H
0.00
NFS
By Code
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480215
8"
FGS
011
046302
101CS2P
12"-FGS-011075302-101CS2P-S
SA-JER-DS011-TRJR-480116
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480116
8"
FGS
011
046302
101CS2P
SA-JER-DS011-TRJR-480215
Reducer
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
8"
FGS
011
046302
101CS2P
8"-FGS-011046302-101CS2P-S
8"-FGS-011046302-101CS2P-S
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
1/2"
FGS
011
046302
101CS2P
011-FE-0076
011-FT-0076-A
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
1/2"
FGS
011
046302
101CS2P
011-FE-0076
011-FT-0076-A
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
8"
FGS
011
046302
101CS2P
8"-FGS-011046302-101CS2P-S
8"-FGS-011046302-101CS2P-S
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
FGS
011
046302
101CS2P
8"-FGS-011046302-101CS2P-S
011-PDT-0198
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
FGS
011
046302
101CS2P
8"-FGS-011046302-101CS2P-S
011-PDT-0198
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
8"
FGS
011
046302
101CS2P
8"-FGS-011046302-101CS2P-S
8"-FGS-011046302-101CS2P-S
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
FGS
011
046302
101CS2P
8"-FGS-011046302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
FGS
011
046302
101CS2P
8"-FGS-011046302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
6"
FGS
011
046302
101CS2P
Reducer
Reducer
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
8"
FGS
011
046302
101CS2P
Reducer
Header
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
2"
FGS
011
046302
101CS2P
8"-FGS-011046302-101CS2P-S
011-F-0001
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
FGS
011
046302
101CS2P
8"-FGS-011046302-101CS2P-S
011-PT-0196
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
FGS
011
046302
101CS2P
8"-FGS-011046302-101CS2P-S
011-PT-0193
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
2"
FGS
011
046302
101CS2P
8"-FGS-011046302-101CS2P-S
011-F-0001
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
FGS
011
046302
101CS2P
8"-FGS-011046302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
FGS
011
046302
101CS2P
8"-FGS-011046302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
FGS
011
046302
101CS2P
8"-FGS-011046302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
FGS
011
046302
101CS2P
8"-FGS-011046302-101CS2P-S
011-PT-0390
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
FGS
011
046302
101CS2P
8"-FGS-011046302-101CS2P-S
011-PI-0189
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
FGS
011
046302
101CS2P
8"-FGS-011046302-101CS2P-S
011-ZV-0055
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3"
FGS
011
046302
101CS2P
8"-FGS-011046302-101CS2P-S
Reducer
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
FGS
011
046302
101CS2P
3"-FGS-011046302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
Page 71 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
INSULATION (NOTE 2)
TYPE
FLUID
THICKNESS (mm)
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480116
2"
FGS
011
046302
101CS2P
8"-FGS-011046302-101CS2P-S
011-F-0001
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
FGS
011
046302
101CS2P
2"-FGS-011046302-101CS2P-S
011-PI-0185
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
2"
FGS
011
046302
101CS2P
Reducer
Reducer
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3"
FGS
011
046302
101CS2P
Reducer
8"-FGS-011046302-101CS2P-S
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
FGS
011
046302
101CS2P
3"-FGS-011046302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
FGS
011
048002
101CS2P
011-ZV-0063
Reducer
-
-
N
-
AIR
Gas
-
0.00
52.30
-
-
0.00
55.00
-
H
0.00
NFS
By Code
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
2"
FGS
011
048002
101CS2P
Reducer
ATM
-
-
N
-
AIR
Gas
-
0.00
52.30
-
-
0.00
55.00
-
Visual Test
0.00
NFS
By Code
A or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480118
3"
FGS
011
048003
101CS2P
6"-FGS-011048302-101CS2P-S
Reducer
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
FGS
011
048003
101CS2P
3"-FGS-011048003-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
2"
FGS
011
048003
101CS2P
Reducer
Reducer
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3"
FGS
011
048003
101CS2P
Reducer
6"-FGS-011048302-101CS2P-S
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
FGS
011
048003
101CS2P
3"-FGS-011048003-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480215
6"
FGS
011
048302
101CS2P
12"-FGS-011075302-101CS2P-S
SA-JER-DS011-TRJR-480118
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480118
6"
FGS
011
048302
101CS2P
SA-JER-DS011-TRJR-480215
Reducer
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
FGS
011
048302
101CS2P
6"-FGS-011048302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
FGS
011
048302
101CS2P
6"-FGS-011048302-101CS2P-S
011-PDT-0216
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
FGS
011
048302
101CS2P
6"-FGS-011048302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
1/2"
FGS
011
048302
101CS2P
011-FE-0080
011-FT-0080
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
FGS
011
048302
101CS2P
6"-FGS-011048302-101CS2P-S
011-PDT-0216
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
1/2"
FGS
011
048302
101CS2P
011-FE-0080
011-FT-0080
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
6"
FGS
011
048302
101CS2P
6"-FGS-011048302-101CS2P-S
6"-FGS-011048302-101CS2P-S
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
4"
FGS
011
048302
101CS2P
Reducer
Reducer
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
6"
FGS
011
048302
101CS2P
Reducer
HEADER
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
FGS
011
048302
101CS2P
6"-FGS-011048302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
FGS
011
048302
101CS2P
6"-FGS-011048302-101CS2P-S
011-PT-0212
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
FGS
011
048302
101CS2P
6"-FGS-011048302-101CS2P-S
011-PI-0211
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
FGS
011
048302
101CS2P
6"-FGS-011048302-101CS2P-S
011-PT-0410
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
FGS
011
048302
101CS2P
6"-FGS-011048302-101CS2P-S
011-PT-0213
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
2"
FGS
011
048302
101CS2P
6"-FGS-011048302-101CS2P-S
011-F-0002
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
FGS
011
048302
101CS2P
6"-FGS-011048302-101CS2P-S
011-ZV-0063
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
FGS
011
048302
101CS2P
6"-FGS-011048302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
FGS
011
048302
101CS2P
6"-FGS-011048302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
2"
FGS
011
048302
101CS2P
6"-FGS-011048302-101CS2P-S
011-F-0002
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
2"
FGS
011
048302
101CS2P
6"-FGS-011048302-101CS2P-S
011-F-0002
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
FGS
011
048302
101CS2P
2"-FGS-011048302-101CS2P-S
011-PI-0205
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
3/4"
FGS
011
049002
101CS2P
011-ZV-0071
Reducer
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
55.00
-
H
0.00
NFS
By Code
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
2"
FGS
011
049002
101CS2P
Reducer
ATM
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
55.00
-
Visual Test
0.00
NFS
By Code
A or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
3"
FGS
011
049003
101CS2P
6"-FGS-011049302-101CS2P-S
Reducer
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
3/4"
FGS
011
049003
101CS2P
3"-FGS-011049003-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
2"
FGS
011
049003
101CS2P
Reducer
Reducer
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
3"
FGS
011
049003
101CS2P
Reducer
6"-FGS-011049302-101CS2P-S
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
3/4"
FGS
011
049003
101CS2P
3"-FGS-011049003-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480215
6"
FGS
011
049302
101CS2P
12"-FGS-011075302-101CS2P-S
SA-JER-DS011-TRJR-480119
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
6"
FGS
011
049302
101CS2P
Reducer
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
1/2"
FGS
011
049302
101CS2P
011-FE-0084
011-FT-0084-A
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
6"
FGS
011
049302
101CS2P
6"-FGS-011049302-101CS2P-S
6"-FGS-011049302-101CS2P-S
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
1/2"
FGS
011
049302
101CS2P
011-FE-0084
011-FT-0084-A
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
3/4"
FGS
011
049302
101CS2P
6"-FGS-011049302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
3/4"
FGS
011
049302
101CS2P
6"-FGS-011049302-101CS2P-S
011-PDT-0243
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
3/4"
FGS
011
049302
101CS2P
6"-FGS-011049302-101CS2P-S
011-PDT-0243
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
4"
FGS
011
049302
101CS2P
Reducer
Reducer
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
6"
FGS
011
049302
101CS2P
Reducer
HEADER
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
3/4"
FGS
011
049302
101CS2P
6"-FGS-011049302-101CS2P-S
011-PT-0229
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
3/4"
FGS
011
049302
101CS2P
6"-FGS-011049302-101CS2P-S
011-ZV-0071
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
3/4"
FGS
011
049302
101CS2P
6"-FGS-011049302-101CS2P-S
011-PI-0228
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
3/4"
FGS
011
049302
101CS2P
6"-FGS-011049302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
3/4"
FGS
011
049302
101CS2P
6"-FGS-011049302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
3/4"
FGS
011
049302
101CS2P
6"-FGS-011049302-101CS2P-S
011-PT-0406
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
2"
FGS
011
049302
101CS2P
6"-FGS-011049302-101CS2P-S
011-F-0002
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
3/4"
FGS
011
049302
101CS2P
6"-FGS-011049302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
3/4"
FGS
011
049302
101CS2P
6"-FGS-011049302-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
2"
FGS
011
049302
101CS2P
6"-FGS-011049302-101CS2P-S
011-F-0002
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
3/4"
FGS
011
049302
101CS2P
6"-FGS-011049302-101CS2P-S
011-PT-0230
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
2"
FGS
011
049302
101CS2P
6"-FGS-011049302-101CS2P-S
011-F-0002
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
3/4"
FGS
011
049302
101CS2P
2"-FGS-011049302-101CS2P-S
011-PI-0240
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
2"
FGS
011
075001
101CS2P
UC
011-D-0015
-
-
P
25
FUEL GAS
Gas
-
3.50
52.00
-
-
3.50
350.00
-
H
6.22
NFS
By Code
M
Y
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290ºC. NOTE 6
SA-JER-DS011-TRJR-480214
3/4"
FGS
011
075001
101CS2P
2"-FGS-011075001-101CS2P-P
Plug
-
-
P
25
FUEL GAS
Gas
-
3.50
52.00
-
-
3.50
350.00
-
H
6.22
NFS
By Code
M
Y
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290ºC. NOTE 6
SA-JER-DS011-TRJR-480214
12"
FGS
011
075301
101CS2P
IP-1326 L
011-ZV-0101
-
-
H
40
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
12"
FGS
011
075301
101CS2P
011-ZV-0101
Blind flange
-
-
H
40
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
1/2"
FGS
011
075301
101CS2P
011-FE-0088
011-FT-0088
-
-
H
25
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
2"
FGS
011
075301
101CS2P
12"-FGS-011075301-101CS2P-H
011-TT-0241
-
-
H
25
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
1/2"
FGS
011
075301
101CS2P
011-FE-0088
011-FT-0088
-
-
H
25
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
3/4"
FGS
011
075301
101CS2P
12"-FGS-011075301-101CS2P-H
011-PT-0261
-
-
H
25
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
3/4"
FGS
011
075301
101CS2P
12"-FGS-011075301-101CS2P-H
011-PI-0264
-
-
H
25
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
2"
FGS
011
075301
101CS2P
12"-FGS-011075301-101CS2P-H
Blind flange
-
-
H
25
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
12"
FGS
011
075302
101CS2P
011-D-0015
SA-JER-DS011-TRJR-480215
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480214
3/4"
FGS
011
075302
101CS2P
12"-FGS-011075302-101CS2P-S
011-PI-0260
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480214
3/4"
FGS
011
075302
101CS2P
011-PT-0376
12"-FGS-011075302-101CS2P-S
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480214
3/4"
FGS
011
075302
101CS2P
011-PT-0259
12"-FGS-011075302-101CS2P-S
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480215
12"
FGS
011
075302
101CS2P
SA-JER-DS011-TRJR-480214
12"-FGS-011075302-101CS2P-S
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480215
12"
FGS
011
075302
101CS2P
HEADER
HEADER
S
36.8
H
40
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480214
4"
FGS
011
075304
101CS2P
011-D-0015
011-SP-0042
-
-
N
-
FUEL GAS
Gas
-
3.50
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 175ºC. NOTE 6
SA-JER-DS011-TRJR-480214
4"
FGS
011
075304
101CS2P
011-SP-0042
Reducer
-
-
N
-
FUEL GAS
Gas
-
3.50
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 175ºC. NOTE 6
SA-JER-DS011-TRJR-480214
1-1/2"
FGS
011
075304
101CS2P
Reducer
011-PZV-0044-A
-
-
N
-
FUEL GAS
Gas
-
3.50
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 175ºC. NOTE 6
SA-JER-DS011-TRJR-480214
2"
FGS
011
075304
101CS2P
4"-FGS-011075304-101CS2P-N
2"-FGS-011075304-101CS2P-N
-
-
N
-
FUEL GAS
Gas
-
3.50
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 175ºC. NOTE 6
SA-JER-DS011-TRJR-480214
2"
FGS
011
075304
101CS2P
2"-FGS-011075304-101CS2P-N
2"-LFL-011075301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
3.50
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 175ºC. NOTE 6
SA-JER-DS011-TRJR-480214
4"
FGS
011
075304
101CS2P
4"-FGS-011075304-101CS2P-N
Reducer
-
-
N
-
FUEL GAS
Gas
-
3.50
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 175ºC. NOTE 6
SA-JER-DS011-TRJR-380001
SA-JER-DS011-TRJR-480215
NORMAL TEMPERATURE 52.3ºC. RANGE TO BE CONSIDERED: 35.8ºC-56ºC. NOTE 6 NORMAL TEMPERATURE 52.3ºC. RANGE TO BE CONSIDERED: 35.8ºC-56ºC. NOTE 6 NORMAL TEMPERATURE 52.3ºC. RANGE TO BE CONSIDERED: 35.8ºC-56ºC. NOTE 6 NORMAL TEMPERATURE 52.3ºC. RANGE TO BE CONSIDERED: 35.8ºC-56ºC. NOTE 6 NORMAL TEMPERATURE 52.3ºC. RANGE TO BE CONSIDERED: 35.8ºC-56ºC. NOTE 6 NORMAL TEMPERATURE 52.3ºC. RANGE TO BE CONSIDERED: 35.8ºC-56ºC. NOTE 6 NORMAL TEMPERATURE 52.3ºC. RANGE TO BE CONSIDERED: 35.8ºC-56ºC. NOTE 6 NORMAL TEMPERATURE 52.3ºC. RANGE TO BE CONSIDERED: 35.8ºC-56ºC. NOTE 6
Page 72 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
INSULATION (NOTE 2)
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC) 80.00
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480214
1-1/2"
FGS
011
075304
101CS2P
Reducer
011-PZV-0044-B
-
-
N
-
FUEL GAS
Gas
-
3.50
52.00
-
-
8.50
-
H
12.75
NFS
By Code
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 175ºC. NOTE 6
SA-JER-DS011-TRJR-480214
2"
FGS
011
075305
101CS2P
011-D-0015
Insul Brk
-
-
N
-
FUEL GAS
Gas
-
3.50
52.00
-
-
8.50
-0.50
155.00
120.00
-
H
12.75
NFS
By Code
A or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480214
2"
FGS
011
075305
101CS2P
Insul Brk
2"-LFL-011075304-101CH2F-S
S
37
H
25
FUEL GAS
Gas
-
3.50
52.00
-
-
8.50
-0.50
155.00
120.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
S
37
H
25
FUEL GAS
Gas
-
3.50
52.00
-
-
8.50
-0.50
155.00
120.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
-0.50
155.00
120.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6 NOTE 6
SA-JER-DS011-TRJR-480214
3/4"
FGS
011
075305
101CS2P
2"-FGS-011075305-101CS2P-S
3/4"-OLW-011075301-101CS1PN
SA-JER-DS011-TRJR-480214
3/4"
FGS
011
075305
101CS2P
011-LG-0081
2"-FGS-011075305-101CS2P-S
S
37
H
25
FUEL GAS
Gas
-
3.50
52.00
-
-
8.50
SA-JER-DS011-TRJR-480214
3/4"
FGS
011
075306
101CS2P
011-LG-0081
3/4"-LFL-011075306-101CH2F-S
S
37
H
25
FUEL GAS
Gas
-
3.50
52.00
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
3/4"
FGS
011
075306
101CS2P 3/4"-FGS-011075306-101CS2P-S
Plug
S
37
H
25
FUEL GAS
Gas
-
3.50
52.00
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
2"
FGS
011
075307
101CS2P
2"-OLW-011075302-101CS1P-N
-
-
N
-
FUEL GAS
Gas
-
3.50
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
2"
FGS
011
075308
101CS2P
011-D-0015 12"-FGS-011075301-101CS2P-H
Insul Brk
-
-
H
25
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
2"
FGS
011
075308
101CS2P
Insul Brk
2"-LFL-011075302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
3/4"
FGS
011
075308
101CS2P
2"-FGS-011075308-101CS2P-N
Plug
-
-
N
-
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
12"
FGS
011
075309
101CS2P
12"-FGS-011075301-101CS2P-H
Reducer
-
-
H
40
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
12"
FGS
011
075309
101CS2P
12"-FGS-011075309-101CS2P-H
Reducer
-
-
H
40
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
4"
FGS
011
075309
101CS2P
Reducer
4"-FGS-011075309-101CS2P-H
-
-
H
25
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
6"
FGS
011
075309
101CS2P
Reducer
Reducer
-
-
H
40
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
12"
FGS
011
075309
101CS2P
Reducer
12"-FGS-011075309-101CS2P-H
-
-
H
40
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
12"
FGS
011
075309
101CS2P
12"-FGS-011075309-101CS2P-H
011-D-0015
-
-
H
40
FUEL GAS
Gas
-
3.50
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
12"
FGS
011
075309
101CS2P
Reducer
12"-FGS-011075309-101CS2P-H
-
-
H
40
FUEL GAS
Gas
-
3.50
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
4"
FGS
011
075309
101CS2P
4"-FGS-011075309-101CS2P-H
Reducer
-
-
H
25
FUEL GAS
Gas
-
3.50
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480214
3/4"
FGS
011
075310
101CS2P
SA-JER-DS011-TRJR-480214
3/4"
FGS
011
075310
SA-JER-DS011-TRJR-480214
3/4"
FGS
011
075311
SA-JER-DS011-TRJR-480274
3/4"
FGS
011
SA-JER-DS011-TRJR-480274
1/2"
FGS
SA-JER-DS011-TRJR-480214
2"
SA-JER-DS011-TRJR-480215
2"
-
H
25
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
-
-
S
36.8
N
-
FUEL GAS
Gas
-
5.00
52.00
-
-
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
SAMPLE CYLINDER
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
12"-FGS-011075301-101CS2P-H
SA-JER-DS011-TRJR-480215
-
-
H
25
FUEL GAS
Gas
-
5.00
SA-JER-DS011-TRJR-480214
HEADER
-
-
H
25
FUEL GAS
Gas
-
5.00
6"-FGS-011075309-101CS2P-H
Insul Brk
101CS2P
Insul Brk
3/4"-LFL-011075305-101CH2F-N
101CS2P
12"-FGS-011075302-101CS2P-S
011-SC-0012
075311
101CS2P
12"-FUG-011075302-101CS2P-S
Reducer
011
075311
101CS2P
Reducer
FGS
011
075312
101CS2P
FGS
011
075312
101CS2P
-
80.00
-
H
12.75
NFS
By Code
8.50
80.00
-
H
12.75
NFS
8.50
155.00
-
H
12.75
NFS
-
8.50
155.00
-
H
12.75
-
-
8.50
155.00
-
H
52.00
-
-
8.50
80.00
-
52.00
-
-
8.50
80.00
-
NOTE 6 NOTE 6 NORMAL TEMPERATURE 52.3ºC. RANGE TO BE CONSIDERED: 35.8ºC-56ºC. NOTE 6 NORMAL TEMPERATURE 52.3ºC. RANGE TO BE CONSIDERED: 35.8ºC-56ºC. NOTE 6 NORMAL TEMPERATURE 52.3ºC. RANGE TO BE CONSIDERED: 35.8ºC-56ºC. NOTE 6 NORMAL TEMPERATURE 52.3ºC. RANGE TO BE CONSIDERED: 35.8ºC-56ºC. NOTE 6 NORMAL TEMPERATURE 52.3ºC. RANGE TO BE CONSIDERED: 35.8ºC-56ºC. NOTE 6 NORMAL TEMPERATURE 52.3ºC. RANGE TO BE CONSIDERED: 35.8ºC-56ºC. NOTE 6 NORMAL TEMPERATURE 52.3ºC. RANGE TO BE CONSIDERED: 35.8ºC-56ºC. NOTE 6 NORMAL TEMPERATURE 52.3ºC. RANGE TO BE CONSIDERED: 35.8ºC-56ºC. NOTE 6 NOTE 6 NOTE 6 NOTE 6 NORMAL TEMPERATURE 52.3ºC. RANGE TO BE CONSIDERED: 35.8ºC-56ºC. NOTE 6 NORMAL TEMPERATURE 52.3ºC. RANGE TO BE CONSIDERED: 35.8ºC-56ºC. NOTE 6
M or Q
Y
N
N
N
N
N
-
By Code
A or Q
Y
N
N
N
N
N
-
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
Y
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150ºC.NOTE 6
Y
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150ºC.NOTE 6
Y
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150ºC. NOTE 6
Y
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150ºC. NOTE 6
Y
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150ºC. NOTE 6
Y
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150ºC. NOTE 6
Y
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150ºC. NOTE 6
Y
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150ºC. NOTE 6
Y
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150ºC. NOTE 6
NOTE 6 NORMAL TEMPERATURE 52.3ºC. RANGE TO BE CONSIDERED: 35.8ºC-56ºC. NOTE 6 NORMAL TEMPERATURE 52.3ºC. RANGE TO BE CONSIDERED: 35.8ºC-56ºC. NOTE 6
if insulated M or Q SA-JER-DS011-TRJR-480214
-
FGS
011
075601
101CS2P
011-D-0015
TRIM
-
-
N
-
-
-
-
3.50
52.00
-
-
3.50
350.00
-
Visual Test
0.00
NFS
By Code
SA-JER-DS011-TRJR-480214
6"
FGS
011
075601
101CS2P
011-D-0015
Blind flange
-
-
H
40
-
-
-
3.50
52.00
-
-
3.50
350.00
-
H
6.22
NFS
By Code
SA-JER-DS011-TRJR-480214
-
FGS
011
075602
103CS2P
011-D-0015
TRIM
-
-
H
-
-
-
-
3.50
52.00
-
-
3.50
350.00
-
Visual Test
0.00
NFS
By Code
SA-JER-DS011-TRJR-480214
2"
FGS
011
075602
101CS2P
011-LG-0081
011-D-0015
-
-
H
25
-
-
-
3.50
52.00
-
-
3.50
350.00
-
H
6.22
NFS
By Code
SA-JER-DS011-TRJR-480214
2"
FGS
011
075602
101CS2P
011-LT-0082
011-D-0015
-
-
H
25
-
-
-
3.50
52.00
-
-
3.50
350.00
-
H
6.22
NFS
By Code
SA-JER-DS011-TRJR-480214
2"
FGS
011
075602
101CS2P
011-D-0015
011-LT-0105
-
-
H
25
-
-
-
3.50
52.00
-
-
3.50
350.00
-
H
6.22
NFS
By Code
SA-JER-DS011-TRJR-480214
2"
FGS
011
075602
101CS2P
011-LG-0081
011-D-0015
S
36.8
H
25
-
-
-
3.50
52.00
-
-
3.50
350.00
-
H
6.22
NFS
By Code
SA-JER-DS011-TRJR-480214
2"
FGS
011
075602
101CS2P
011-D-0015
011-LT-0105
-
-
H
25
-
-
-
3.50
52.00
-
-
3.50
350.00
-
H
6.22
NFS
By Code
SA-JER-DS011-TRJR-480214
2"
FGS
011
075602
101CS2P
011-LT-0082
011-D-0015
-
-
H
25
-
-
-
3.50
52.00
-
-
3.50
350.00
-
H
6.22
NFS
By Code
SA-JER-DS011-TRJR-480214
2"
FGS
011
076301
101CS2P
2"-FGS-011075301-101CS2P-H
SA-JER-DS011-TRJR-480218
-
-
H
25
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NORMAL TEMPERATURE 52.3ºC. RANGE TO BE CONSIDERED: 35.8ºC-56ºC. NOTE 6
SA-JER-DS011-TRJR-480218
2"
FGS
011
076301
101CS2P
SA-JER-DS011-TRJR-480214
2"-LFL-011076305-101CH2F-H
-
-
H
25
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480218
2"
FGS
011
076301
101CS2P
2"-FGS-011076301-101CS2P-H
2"-FGS-011076301-101CS2P-H
-
-
H
25
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480215
2"
FGS
011
076302
101CS2P
2"-FGS-011075312-101CS2P-H
SA-JER-DS011-TRJR-480221
-
-
H
25
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480221
2"
FGS
011
076302
101CS2P
SA-JER-DS011-TRJR-480215
2"-LFL-011076306-101CH2F-H
-
-
H
25
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480221
2"
FGS
011
076302
101CS2P
2"-FGS-011076302-101CS2P-H
2"-FGS-011076302-101CS2P-H
-
-
H
25
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480215
2"
FGS
011
076303
101CS2P
2"-FGS-011075312-101CS2P-H
SA-JER-DS011-TRJR-480221
-
-
H
25
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480221
2"
FGS
011
076303
101CS2P
SA-JER-DS011-TRJR-480215
2"-LFL-011076307-101CH2F-H
-
-
H
25
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480221
2"
FGS
011
076303
101CS2P
2"-FGS-011076303-101CS2P-H
2"-FGS-011076303-101CS2P-H
-
-
H
25
FUEL GAS
Gas
-
5.00
52.00
-
-
8.50
80.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
1/2"
FGS
011
200301
101CS2P
SAMPLE CYLINDER
Reducer
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
FGS
011
200301
101CS2P
Reducer
3/4"-LFL-011200305-101CH2F-N
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
FGS
011
200301
101CS2P 3/4"-FGS-011200301-101CS2P-S
Plug
S
36.8
H
25
FUEL GAS
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480242
2"
FLO
011
001303
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480002
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
2"
FLO
011
001303
101CS1P
SA-JER-DS011-TRJR-480242
2"-CRU-011001003-106CS1P-N
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480242
2"
FLO
011
001304
101CS1P
2"-FLO-011001303-101CS1P-N
SA-JER-DS011-TRJR-480002
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
2"
FLO
011
001304
101CS1P
SA-JER-DS011-TRJR-480242
2"-CRU-011001004-106CS1P-N
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
2"
FLO
011
002301
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480004
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
FLO
011
002301
101CS1P
SA-JER-DS011-TRJR-480223
2"-CRU-011001007-106CS1P-N
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
2"
FLO
011
002302
101CS1P
2"-FLO-011002301-101CS1P-N
SA-JER-DS011-TRJR-480004
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
FLO
011
002302
101CS1P
SA-JER-DS011-TRJR-480223
2"-CRU-011001007-106CS1P-N
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
2"
FLO
011
003301
101CS1P
2"-FLO-011010301-101CS1P-N
SA-JER-DS011-TRJR-480005
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
170.00
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
FLO
011
003301
101CS1P
SA-JER-DS011-TRJR-480243
2"-CRU-011003002-106CS1P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
170.00
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
2"
FLO
011
003302
101CS1P
2"-FLO-011010301-101CS1P-N
SA-JER-DS011-TRJR-480005
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
170.00
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
FLO
011
003302
101CS1P
SA-JER-DS011-TRJR-480243
2"-CRU-011003002-106CS1P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
170.00
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480242
2"
FLO
011
003303
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480006
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480006
2"
FLO
011
003303
101CS1P
SA-JER-DS011-TRJR-480242
2"-CRU-011003003-106CS1P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480242
3"
FLO
011
005301
101CS1P
6"-FLO-011077301-101CS1P-N
Reducer
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
Page 73 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480242
2"
FLO
011
005301
101CS1P
Reducer
SA-JER-DS011-TRJR-480010
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
FLO
011
005301
101CS1P
SA-JER-DS011-TRJR-480242
2"-CRU-011005002-106CS1P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480242
3"
FLO
011
005302
101CS1P
3"-FLO-011005301-101CS1P-N
Reducer
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480242
2"
FLO
011
005302
101CS1P
Reducer
SA-JER-DS011-TRJR-480010
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
FLO
011
005302
101CS1P
SA-JER-DS011-TRJR-480242
2"-CRU-011005002-106CS1P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480242
3"
FLO
011
005303
101CS1P
3"-FLO-011005301-101CS1P-N
Reducer
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480242
2"
FLO
011
005303
101CS1P
Reducer
SA-JER-DS011-TRJR-480010
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
FLO
011
005303
101CS1P
SA-JER-DS011-TRJR-480242
2"-HFO-011009001-103CL2P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480242
3"
FLO
011
005304
101CS1P
3"-FLO-011005302-101CS1P-N
Reducer
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480242
2"
FLO
011
005304
101CS1P
Reducer
SA-JER-DS011-TRJR-480010
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
FLO
011
005304
101CS1P
SA-JER-DS011-TRJR-480242
2"-HFO-011009001-103CL2P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480242
3"
FLO
011
006301
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480011
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480011
3"
FLO
011
006301
101CS1P
SA-JER-DS011-TRJR-480242
3"-CRU-011006006-103CS2P-H
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480242
3"
FLO
011
007301
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480012
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480012
3"
FLO
011
007301
101CS1P
SA-JER-DS011-TRJR-480242
3"-CRU-011007002-103CS1P-H
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480242
2"
FLO
011
008301
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480015
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
2"
FLO
011
008301
101CS1P
SA-JER-DS011-TRJR-480242
2"-CRU-011008011-103CS1P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480242
2"
FLO
011
008302
101CS1P
2"-FLO-011008301-101CS1P-N
SA-JER-DS011-TRJR-480015
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480015
2"
FLO
011
008302
101CS1P
SA-JER-DS011-TRJR-480242
2"-CRU-011008012-103CS1P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
2"
FLO
011
008303
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480016
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
2"
FLO
011
008303
101CS1P
SA-JER-DS011-TRJR-480243
2"-CRU-011008003-103CS1P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
2"
FLO
011
008304
101CS1P
4"-FLO-011038304-101CS1P-N
SA-JER-DS011-TRJR-480016
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
2"
FLO
011
008304
101CS1P
SA-JER-DS011-TRJR-480243
2"-HFO-011013002-103CS1P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
4"
FLO
011
010301
101CS1P
6"-FLO-011077301-101CS1P-N
Reducer
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
2"
FLO
011
010301
101CS1P
Reducer
SA-JER-DS011-TRJR-480019
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480019
2"
FLO
011
010301
101CS1P
SA-JER-DS011-TRJR-480243
2"-CRU-011010005-101CH2S-H
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
2"
FLO
011
011301
101CS1P
4"-FLO-011010301-101CS1P-N
SA-JER-DS011-TRJR-480021
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
2"
FLO
011
011301
101CS1P
SA-JER-DS011-TRJR-480243
2"-CRU-011011002-106CS1P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
2"
FLO
011
011302
101CS1P
4"-FLO-011010301-101CS1P-N
SA-JER-DS011-TRJR-480021
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480021
2"
FLO
011
011302
101CS1P
SA-JER-DS011-TRJR-480243
2"-CRU-011011003-106CS1P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480224
2"
FLO
011
013302
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480025
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
FLO
011
013302
101CS1P
SA-JER-DS011-TRJR-480224
2"-HFO-011015003-103CL2P-S
-
-
N
-
FLUSHING OIL
Liquid
802
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480224
4"
FLO
011
013303
101CS1P
6"-FLO-011077301-101CS1P-N
Reducer
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480224
2"
FLO
011
013303
101CS1P
Reducer
2"-FLO-011014302-101CS1P-N
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
FLO
011
013303
101CS1P
SA-JER-DS011-TRJR-480224
2"-HFO-011015003-103CL2P-S
-
-
N
-
FLUSHING OIL
Liquid
802
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480224
2"
FLO
011
013303
101CS1P
4"-FLO-011013303-101CS1P-N
SA-JER-DS011-TRJR-480025
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
2"
FLO
011
013304
101CS1P
6"-FLO-011077302-101CS1P-N
SA-JER-DS011-TRJR-480141
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
2"
FLO
011
013304
101CS1P
SA-JER-DS011-TRJR-480222
2"-HFO-011013003-103CL2P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
2"
FLO
011
013305
101CS1P
6"-FLO-011077302-101CS1P-N
SA-JER-DS011-TRJR-480141
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
2"
FLO
011
013305
101CS1P
SA-JER-DS011-TRJR-480222
2"-HFO-011013003-103CL2P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
4"
FLO
011
013308
101CS1P
SA-JER-DS011-TRJR-480222
4"-HFO-011013006-101SD0P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
4"
FLO
011
013308
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480141
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480224
2"
FLO
011
013309
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480024
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
FLO
011
013309
101CS1P
SA-JER-DS011-TRJR-480224
2"-CRU-011013002-106CS1P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480224
2"
FLO
011
013310
101CS1P
4"-FLO-011013303-101CS1P-N
SA-JER-DS011-TRJR-480025
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
FLO
011
013310
101CS1P
SA-JER-DS011-TRJR-480224
2"-CRU-011013004-106CS1P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480224
2"
FLO
011
013311
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480025
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
FLO
011
013311
101CS1P
SA-JER-DS011-TRJR-480224
2"-CRU-011013003-106CS1P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480224
2"
FLO
011
014301
101CS1P
4"-FLO-011013303-101CS1P-N
SA-JER-DS011-TRJR-480027
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
FLO
011
014301
101CS1P
SA-JER-DS011-TRJR-480224
2"-CRU-011014003-106CS2P-P
-
-
N
-
FLUSHING OIL
Liquid
760
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480224
2"
FLO
011
014302
101CS1P
2"-FLO-011013303-101CS1P-N
SA-JER-DS011-TRJR-480027
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
FLO
011
014302
101CS1P
SA-JER-DS011-TRJR-480224
2"-HFO-011015103-103CL4P-S
-
-
N
-
FLUSHING OIL
Liquid
929
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480224
2"
FLO
011
014303
101CS1P
2"-FLO-011014307-101CS1P-N
SA-JER-DS011-TRJR-480027
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
FLO
011
014303
101CS1P
SA-JER-DS011-TRJR-480224
2"-CRU-011014003-106CS2P-P
-
-
N
-
FLUSHING OIL
Liquid
760
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480224
2"
FLO
011
014304
101CS1P
2"-FLO-011014307-101CS1P-N
SA-JER-DS011-TRJR-480027
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
FLO
011
014304
101CS1P
SA-JER-DS011-TRJR-480224
2"-HFO-011015103-103CL4P-S
-
-
N
-
FLUSHING OIL
Liquid
760
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480224
2"
FLO
011
014305
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480027
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
2"
FLO
011
014305
101CS1P
SA-JER-DS011-TRJR-480224
2"-HFO-011014103-103CL2P-S
-
-
N
-
FLUSHING OIL
Liquid
929
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480224
4"
FLO
011
014307
101CS1P
6"-FLO-011077301-101CS1P-N
Reducer
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480224
2"
FLO
011
014307
101CS1P
Reducer
2"-FLO-011014303-101CS1P-N
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
FLO
011
014307
101CS1P
SA-JER-DS011-TRJR-480224
2"-HFO-011022002-103CL2P-P
-
-
N
-
FLUSHING OIL
Liquid
697
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480224
4"
FLO
011
014307
101CS1P
4"-FLO-011014307-101CS1P-N
Reducer
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480224
2"
FLO
011
014307
101CS1P
Reducer
2"-FLO-011014304-101CS1P-N
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480224
2"
FLO
011
014307
101CS1P
4"-FLO-011014307-101CS1P-N
SA-JER-DS011-TRJR-480026
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480224
2"
FLO
011
014308
101CS1P
4"-FLO-011013303-101CS1P-N
SA-JER-DS011-TRJR-480026
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
FLO
011
014308
101CS1P
SA-JER-DS011-TRJR-480224
2"-HFO-011022002-103CL2P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
3"
FLO
011
015301
101CS1P
6"-FLO-011077301-101CS1P-N
Reducer
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
2"
FLO
011
015301
101CS1P
Reducer
SA-JER-DS011-TRJR-480028
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
FLO
011
015301
101CS1P
SA-JER-DS011-TRJR-480223
2"-CRU-011015004-106CL2P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
3"
FLO
011
015302
101CS1P
3"-FLO-011015301-101CS1P-N
Reducer
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
2"
FLO
011
015302
101CS1P
Reducer
SA-JER-DS011-TRJR-480028
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
FLO
011
015302
101CS1P
SA-JER-DS011-TRJR-480223
2"-HFO-011039003-103CL2P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
3"
FLO
011
015303
101CS1P
3"-FLO-011015304-101CS1P-N
Reducer
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
2"
FLO
011
015303
101CS1P
Reducer
SA-JER-DS011-TRJR-480028
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
FLO
011
015303
101CS1P
SA-JER-DS011-TRJR-480223
2"-CRU-011015004-106CL2P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
3"
FLO
011
015304
101CS1P
6"-FLO-011077301-101CS1P-N
Reducer
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
2"
FLO
011
015304
101CS1P
Reducer
SA-JER-DS011-TRJR-480028
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
FLO
011
015304
101CS1P
SA-JER-DS011-TRJR-480223
2"-HFO-011039003-103CL2P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
3"
FLO
011
015305
101CS1P
3"-FLO-011015306-101CS1P-N
Reducer
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
2"
FLO
011
015305
101CS1P
Reducer
SA-JER-DS011-TRJR-480029
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
FLO
011
015305
101CS1P
SA-JER-DS011-TRJR-480223
2"-HFO-011039103-103CL4P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
3"
FLO
011
015306
101CS1P
6"-FLO-011077301-101CS1P-N
Reducer
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
2"
FLO
011
015306
101CS1P
Reducer
SA-JER-DS011-TRJR-480029
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
FLO
011
015306
101CS1P
SA-JER-DS011-TRJR-480223
2"-CRU-011015007-106CL2P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
3"
FLO
011
015308
101CS1P
6"-FLO-011077301-101CS1P-N
Reducer
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
2"
FLO
011
015308
101CS1P
Reducer
SA-JER-DS011-TRJR-480029
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
FLO
011
015308
101CS1P
SA-JER-DS011-TRJR-480223
2"-CRU-011015007-106CL2P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
3"
FLO
011
015309
101CS1P
3"-FLO-011015308-101CS1P-N
Reducer
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
2"
FLO
011
015309
101CS1P
Reducer
SA-JER-DS011-TRJR-480029
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
2"
FLO
011
015309
101CS1P
SA-JER-DS011-TRJR-480223
2"-HFO-011039103-103CL4P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
2"
FLO
011
018301
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480044
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 74 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
INSULATION (NOTE 2)
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480044
2"
FLO
011
018301
101CS1P
SA-JER-DS011-TRJR-480222
2"-CRU-011018001-101CL4P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
4"
FLO
011
018302
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480043
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
4"
FLO
011
018302
101CS1P
SA-JER-DS011-TRJR-480222
4"-DIE-011018003-101CS1P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
2"
FLO
011
027301
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480065
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
2"
FLO
011
027301
101CS1P
SA-JER-DS011-TRJR-480223
2"-HFO-011027001-103CL2P-H
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
2"
FLO
011
027302
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480066
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
2"
FLO
011
027302
101CS1P
SA-JER-DS011-TRJR-480223
2"-HFO-011027101-103CL4P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
2"
FLO
011
027303
101CS1P
2"-FLO-011027302-101CS1P-N
SA-JER-DS011-TRJR-480066
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
2"
FLO
011
027303
101CS1P
SA-JER-DS011-TRJR-480223
2"-HFO-011027102-103CL4P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
2"
FLO
011
027306
101CS1P
2"-FLO-011027301-101CS1P-N
SA-JER-DS011-TRJR-480065
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
2"
FLO
011
027306
101CS1P
SA-JER-DS011-TRJR-480223
2"-HFO-011027002-103CL2P-H
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
2"
FLO
011
030301
101CS1P
4"-FLO-011039301-101CS1P-N
SA-JER-DS011-TRJR-480081
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480081
2"
FLO
011
030301
101CS1P
SA-JER-DS011-TRJR-480222
2"-HFO-011030109-101CM2P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
4"
FLO
011
030302
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480081
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480081
4"
FLO
011
030302
101CS1P
SA-JER-DS011-TRJR-480222
4"-HFO-011014104-101CL2P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
4"
FLO
011
037301
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480080
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
4"
FLO
011
037301
101CS1P
SA-JER-DS011-TRJR-480222
4"-DIE-011030002-101CS1P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
2"
FLO
011
038302
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480099
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
170.00
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
2"
FLO
011
038302
101CS1P
SA-JER-DS011-TRJR-480222
2"-HFO-011038001-103CL2P-S
-
-
N
-
FLUSHING OIL
Liquid
775
15.30
50.00
-
170.00
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
2"
FLO
011
038303
101CS1P
2"-FLO-011038302-101CS1P-N
SA-JER-DS011-TRJR-480099
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
170.00
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
2"
FLO
011
038303
101CS1P
SA-JER-DS011-TRJR-480222
2"-HFO-011038002-103CL2P-S
-
-
N
-
FLUSHING OIL
Liquid
775
15.30
50.00
-
170.00
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
4"
FLO
011
038304
101CS1P
6"-FLO-011077301-101CS1P-N
Reducer
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
2"
FLO
011
038304
101CS1P
Reducer
SA-JER-DS011-TRJR-480100
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
2"
FLO
011
038304
101CS1P
SA-JER-DS011-TRJR-480243
2"-HFO-011008001-103CS1P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
2"
FLO
011
038305
101CS1P
4"-FLO-011038304-101CS1P-N
SA-JER-DS011-TRJR-480100
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
2"
FLO
011
038305
101CS1P
SA-JER-DS011-TRJR-480243
2"-HFO-011038004-103CS1P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
2"
FLO
011
038306
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480100
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
2"
FLO
011
038306
101CS1P
SA-JER-DS011-TRJR-480243
2"-HFO-011038005-103CS1P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
2"
FLO
011
038307
101CS1P
4"-FLO-011038304-101CS1P-N
SA-JER-DS011-TRJR-480100
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
2"
FLO
011
038307
101CS1P
SA-JER-DS011-TRJR-480243
2"-HFO-011040120-103CS1P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
2"
FLO
011
038308
101CS1P
4"-FLO-011038304-101CS1P-N
SA-JER-DS011-TRJR-480100
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
2"
FLO
011
038308
101CS1P
SA-JER-DS011-TRJR-480243
2"-HFO-011038023-103CS1P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
ASME N/A
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
4"
FLO
011
039301
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480101
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
4"
FLO
011
039301
101CS1P
SA-JER-DS011-TRJR-480222
4"-HFO-011030001-101CL2P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
2"
FLO
011
039302
101CS1P
4"-FLO-011037301-101CS1P-N
SA-JER-DS011-TRJR-480101
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
2"
FLO
011
039302
101CS1P
SA-JER-DS011-TRJR-480222
2"-HFO-011039001-103CL2P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
2"
FLO
011
039303
101CS1P
4"-FLO-011037301-101CS1P-N
SA-JER-DS011-TRJR-480101
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
2"
FLO
011
039303
101CS1P
SA-JER-DS011-TRJR-480222
2"-HFO-011039002-103CL2P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
2"
FLO
011
039304
101CS1P
6"-FLO-011077302-101CS1P-N
SA-JER-DS011-TRJR-480102
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
2"
FLO
011
039304
101CS1P
SA-JER-DS011-TRJR-480222
2"-HFO-011039004-103CL2P-S
-
-
N
-
FLUSHING OIL
Liquid
775
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
2"
FLO
011
039305
101CS1P
2"-FLO-011039304-101CS1P-N
SA-JER-DS011-TRJR-480102
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
2"
FLO
011
039305
101CS1P
SA-JER-DS011-TRJR-480222
2"-HFO-011039013-103CL2P-S
-
-
N
-
FLUSHING OIL
Liquid
775
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
4"
FLO
011
039306
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480103
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
4"
FLO
011
039306
101CS1P
4"-FLO-011039306-101CS1P-N
Reducer
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480103
4"
FLO
011
039306
101CS1P
SA-JER-DS011-TRJR-480222
4"-HFO-011030101-103CL4P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
2"
FLO
011
039307
101CS1P
Reducer
SA-JER-DS011-TRJR-480103
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480103
2"
FLO
011
039307
101CS1P
SA-JER-DS011-TRJR-480222
2"-HFO-011039101-103CL4P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
2"
FLO
011
039308
101CS1P
4"-FLO-011039306-101CS1P-N
SA-JER-DS011-TRJR-480103
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
2"
FLO
011
039309
101CS1P
4"-FLO-011039301-101CS1P-N
SA-JER-DS011-TRJR-480103
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480103
2"
FLO
011
039309
101CS1P
SA-JER-DS011-TRJR-480222
2"-HFO-011039104-103CL4P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
2"
FLO
011
039310
101CS1P
4"-FLO-011039301-101CS1P-N
SA-JER-DS011-TRJR-480103
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480103
2"
FLO
011
039310
101CS1P
SA-JER-DS011-TRJR-480222
1"-HFO-011027105-103CL4P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
2"
FLO
011
040301
101CS1P
4"-FLO-011040303-101CS1P-N
SA-JER-DS011-TRJR-480104
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480104
2"
FLO
011
040301
101CS1P
SA-JER-DS011-TRJR-480243
2"-HFO-011040102-103CS1P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
2"
FLO
011
040302
101CS1P
4"-FLO-011040303-101CS1P-N
SA-JER-DS011-TRJR-480104
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480104
2"
FLO
011
040302
101CS1P
SA-JER-DS011-TRJR-480243
2"-HFO-011040101-103CS1P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
4"
FLO
011
040303
101CS1P
6"-FLO-011077301-101CS1P-N
Reducer
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
2"
FLO
011
040303
101CS1P
Reducer
SA-JER-DS011-TRJR-480104
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480104
2"
FLO
011
040303
101CS1P
SA-JER-DS011-TRJR-480243
2"-HFO-011040105-103CS1P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
2"
FLO
011
040304
101CS1P
4"-FLO-011040303-101CS1P-N
SA-JER-DS011-TRJR-480104
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480104
2"
FLO
011
040304
101CS1P
SA-JER-DS011-TRJR-480243
2"-HFO-011040103-103CS1P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
2"
FLO
011
040306
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480104
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480104
2"
FLO
011
040306
101CS1P
SA-JER-DS011-TRJR-480243
2"-HFO-011010103-103CS1P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
2"
FLO
011
040307
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480104
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480104
2"
FLO
011
040307
101CS1P
SA-JER-DS011-TRJR-480243
2"-HFO-011040106-103CS1P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480225
2"
FLO
011
076301
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480219
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
ASME N/A
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
2"
FLO
011
076301
101CS1P
SA-JER-DS011-TRJR-480225
2"-SLP-011076004-103CH2S-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
ASME N/A
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480225
2"
FLO
011
076302
101CS1P
2"-FLO-011076301-101CS1P-N
SA-JER-DS011-TRJR-480219
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
ASME N/A
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
2"
FLO
011
076302
101CS1P
SA-JER-DS011-TRJR-480225
2"-SLP-011076003-103CH2S-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
ASME N/A
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480225
3/4"
FLO
011
077001
101CS1P
6"-FLO-011077301-101CS1P-N
Reducer
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480225
2"
FLO
011
077001
101CS1P
Reducer
2"-CLD-011077301-101CH2S-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480225
6"
FLO
011
077301
101CS1P
IP-1320 L
SA-JER-DS011-TRJR-480242
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480242
6"
FLO
011
077301
101CS1P
SA-JER-DS011-TRJR-480225
SA-JER-DS011-TRJR-480243
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
6"
FLO
011
077301
101CS1P
SA-JER-DS011-TRJR-480242
HEADER
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480242
6"
FLO
011
077301
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480224
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480224
6"
FLO
011
077301
101CS1P
SA-JER-DS011-TRJR-480242
SA-JER-DS011-TRJR-480223
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
6"
FLO
011
077301
101CS1P
SA-JER-DS011-TRJR-480224
SA-JER-DS011-TRJR-480222
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
6"
FLO
011
077301
101CS1P
SA-JER-DS011-TRJR-480223
HEADER
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
6"
FLO
011
077302
101CS1P
6"-FLO-011077301-101CS1P-N
HEADER
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480225
2"
FLO
011
078301
101CS1P
2"-FLO-011076302-101CS1P-N
SA-JER-DS011-TRJR-480228
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480228
2"
FLO
011
078301
101CS1P
SA-JER-DS011-TRJR-480225
2"-CLD-011078327-101CH2S-N
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480225
2"
FLO
011
078302
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480229
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480229
2"
FLO
011
078302
101CS1P
SA-JER-DS011-TRJR-480225
2"-CLD-011078341-101CH2S-N
-
-
N
-
FLUSHING OIL
Liquid
1000
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
2"
FLO
011
078304
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480226
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480226
2"
FLO
011
078304
101CS1P
SA-JER-DS011-TRJR-480222
2"-CLD-011078328-101CH2S-N
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
2"
FLO
011
078305
101CS1P
6"-FLO-011077302-101CS1P-N
SA-JER-DS011-TRJR-480226
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480226
2"
FLO
011
078305
101CS1P
SA-JER-DS011-TRJR-480222
2"-CLD-011078329-101CH2S-N
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
2"
FLO
011
078306
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480227
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480227
2"
FLO
011
078306
101CS1P
SA-JER-DS011-TRJR-480223
2"-CLD-011078330-101CH2S-N
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
2"
FLO
011
078308
101CS1P
4"-FLO-011010301-101CS1P-N
SA-JER-DS011-TRJR-480231
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480231
2"
FLO
011
078308
101CS1P
SA-JER-DS011-TRJR-480243
2"-CLD-011078324-101CH2S-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 75 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480222
2"
FLO
011
078309
101CS1P
6"-FLO-011077302-101CS1P-N
SA-JER-DS011-TRJR-480226
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480226
2"
FLO
011
078309
101CS1P
SA-JER-DS011-TRJR-480222
2"-CLD-011078336-101CH2S-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
2"
FLO
011
078310
101CS1P
2"-FLO-011078306-101CS1P-N
SA-JER-DS011-TRJR-480227
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480227
2"
FLO
011
078310
101CS1P
SA-JER-DS011-TRJR-480223
2"-CLD-011078337-101CH2S-N
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
ASME N/A
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480225
2"
FLO
011
078311
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480229
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480229
2"
FLO
011
078311
101CS1P
SA-JER-DS011-TRJR-480225
2"-CLD-011078338-101CH2S-N
-
-
N
-
FLUSHING OIL
Liquid
1000
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480225
2"
FLO
011
078312
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480229
-
-
N
-
FLUSHING OIL
Liquid
1000
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480229
2"
FLO
011
078312
101CS1P
SA-JER-DS011-TRJR-480225
2"-CLD-011078339-101CH2S-N
-
-
N
-
FLUSHING OIL
Liquid
1000
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
2"
FLO
011
078315
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480216
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
200.00
-
H
27.44
NFS
By Code
B or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480216
2"
FLO
011
078315
101CS1P
SA-JER-DS011-TRJR-480243
2"-CLD-011078340-101CH2S-N
-
-
N
-
FLUSHING OIL
Liquid
1000
15.30
50.00
-
-
18.29
200.00
-
H
27.44
NFS
By Code
B or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
2"
FLO
011
078317
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480230
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480230
2"
FLO
011
078317
101CS1P
SA-JER-DS011-TRJR-480222
2"-CLD-011078342-101CH2S-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
ASME N/A
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480222
2"
FLO
011
078319
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480231
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480231
2"
FLO
011
078319
101CS1P
SA-JER-DS011-TRJR-480222
2"-CLD-011078345-101CH2S-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480242
2"
FLO
011
078320
101CS1P
3"-FLO-011007301-101CS1P-N
SA-JER-DS011-TRJR-480231
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480231
2"
FLO
011
078320
101CS1P
SA-JER-DS011-TRJR-480242
2"-CLD-011078346-101CH2S-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480225
2"
FLO
011
098301
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480133
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480133
2"
FLO
011
098301
101CS1P
SA-JER-DS011-TRJR-480225
2"-CRU-011098001-103CS1P-N
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480225
2"
FLO
011
098302
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480136
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
2"
FLO
011
098302
101CS1P
SA-JER-DS011-TRJR-480225
2"-SLP-011098019-103CS1P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480225
6"
FLO
011
099301
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480138
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480138
6"
FLO
011
099301
101CS1P
SA-JER-DS011-TRJR-480225
6"-FLO-011099305-103CS1P-N
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480225
2"
FLO
011
099302
101CS1P
2"-FLO-011099303-101CS1P-N
SA-JER-DS011-TRJR-480138
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480138
2"
FLO
011
099302
101CS1P
SA-JER-DS011-TRJR-480225
2"-HFO-011099103-103CS1P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480225
2"
FLO
011
099303
101CS1P
6"-FLO-011099301-101CS1P-N
SA-JER-DS011-TRJR-480138
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480138
2"
FLO
011
099303
101CS1P
SA-JER-DS011-TRJR-480225
2"-HFO-011099003-103CS1P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480225
4"
FLO
011
099304
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480138
-
-
N
-
FLUSHING OIL
Liquid
862.5
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480138
4"
FLO
011
099304
101CS1P
SA-JER-DS011-TRJR-480225
4"-HFO-011099104-103CS1P-P
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480138
6"
FLO
011
099305
103CS1P
Insul Brk
6"-SLP-011099001-103CS1P-S
S
41
H
40
FLUSHING OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480138
6"
FLO
011
099305
103CS1P
6"-FLO-011099301-101CS1P-N
Insul Brk
-
-
N
-
FLUSHING OIL
Liquid
862.5
7.00
50.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480225
3"
FLO
011
099306
101CS1P
6"-FLO-011077301-101CS1P-N
Reducer
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480225
1-1/2"
FLO
011
099306
101CS1P
Reducer
011-PZV-0093
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480243
3/4"
FLO
011
200302
101CS1P
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480273
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
3/4"
FLO
011
200302
101CS1P
SA-JER-DS011-TRJR-480243
3/4"-HFO-011040114-103CS1P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480223
3/4"
FLO
011
200303
101CS1P
2"-FLO-011027302-101CS1P-N
SA-JER-DS011-TRJR-480273
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
3/4"
FLO
011
200303
101CS1P
SA-JER-DS011-TRJR-480223
1"-HFO-011027110-103CL4P-S
-
-
N
-
FLUSHING OIL
Liquid
850
15.30
50.00
-
-
18.29
80.00
-
H
27.44
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480117
2"
FLU
011
047301
103CS1P
Blind flange
1/2"-FLU-011047301-103CS1P-P
-
-
P
25
FLUE GAS
Gas
-
13.80
270.00
-
-
19.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
1/2"
FLU
011
047301
103CS1P
2"-FLU-011047301-103CS1P-P
Plug
-
-
P
25
FLUE GAS
Gas
-
13.80
270.00
-
-
19.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480120
2"
FLU
011
050301
101CS1P
Blind flange
1/2"-FLU-011050301-101CS1P-P
-
-
P
40
FLUE GAS
Gas
-
13.80
270.00
-
-
19.00
350.00
-
H
29.40
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480120
1/2"
FLU
011
050301
101CS1P
2"-FLU-011050301-101CS1P-P
Plug
-
-
P
40
FLUE GAS
Gas
-
13.80
270.00
-
-
19.00
350.00
-
H
29.40
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480120
1/2"
FLU
011
050301
101CS1P
2"-FLU-011050301-101CS1P-P
Gate valve
-
-
P
40
FLUE GAS
Gas
-
13.80
270.00
-
-
19.00
350.00
-
H
29.40
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480120
1/2"
FLU
011
050301
101CS1P
2"-FLU-011050301-101CS1P-P
Gate valve
-
-
P
40
FLUE GAS
Gas
-
13.80
270.00
-
-
19.00
350.00
-
H
29.40
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480120
1-1/2"
FLU
011
050301
101CS1P
2"-FLU-011050301-101CS1P-P
Gate valve
-
-
P
40
FLUE GAS
Gas
-
13.80
270.00
-
-
19.00
350.00
-
H
29.40
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480120
1/2"
FLU
011
050301
101CS1P
2"-FLU-011050301-101CS1P-P
Gate valve
-
-
P
40
FLUE GAS
Gas
-
13.80
270.00
-
-
19.00
350.00
-
H
29.40
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480120
1-1/2"
FLU
011
050301
101CS1P
2"-FLU-011050301-101CS1P-P
Gate valve
-
-
P
40
FLUE GAS
Gas
-
13.80
270.00
-
-
19.00
350.00
-
H
29.40
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480120
1/2"
FLU
011
050301
101CS1P
2"-FLU-011050301-101CS1P-P
Gate valve
-
-
P
40
FLUE GAS
Gas
-
13.80
270.00
-
-
19.00
350.00
-
H
29.40
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480120
1/2"
FLU
011
050301
101CS1P
2"-FLU-011050301-101CS1P-P
Gate valve
-
-
P
40
FLUE GAS
Gas
-
13.80
270.00
-
-
19.00
350.00
-
H
29.40
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480120
1/2"
FLU
011
050301
101CS1P
2"-FLU-011050301-101CS1P-P
Gate valve
-
-
P
40
FLUE GAS
Gas
-
13.80
270.00
-
-
19.00
350.00
-
H
29.40
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480120
1-1/2"
FLU
011
050602
103CS1P
1-1/2"-FLU-011050602-103CS1PH
Gate valve
-
-
H
50
FLUE GAS
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480120
1-1/2"
FLU
011
050602
103CS1P
011-F-0002
011-PT-0411-A
-
-
H
50
-
-
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480085
6"
GAS
011
032001
101CH4S
011-E-0028
SA-JER-DS011-TRJR-480089
-
-
P
25
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
M
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480085
1"
GAS
011
032001
101CH4S
6"-GAS-011032001-101CH4S-P
011-PI-0077
-
-
P
25
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
M
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480089
6"
GAS
011
032001
101CH4S
SA-JER-DS011-TRJR-480085
011-D-0009
-
-
P
25
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
M
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480086
4"
GAS
011
033001
101CH4S
011-D-0008
SA-JER-DS011-TRJR-480089
-
-
N
-
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
NFS
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480089
4"
GAS
011
033001
101CH4S
SA-JER-DS011-TRJR-480086
011-D-0009
-
-
N
-
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
NFS
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480086
10"
GAS
011
033002
101CH4S
011-D-0008
SA-JER-DS011-TRJR-480086
10"
GAS
011
033002
101CH4S
SA-JER-DS011-TRJR-480086
6"
GAS
011
033002
101CH4S
SA-JER-DS011-TRJR-480086
10"
GAS
011
033002
SA-JER-DS011-TRJR-480086
10"
GAS
011
SA-JER-DS011-TRJR-480086
6"
GAS
SA-JER-DS011-TRJR-480086
2"
SA-JER-DS011-TRJR-480086
NOTE 6 NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTES 6, 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTES 6, 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTES 6, 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTES 6, 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTES 6, 10
011-SP-0030
-
-
N
-
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
NFS
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
011-SP-0030
Reducer
-
-
N
-
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
NFS
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
Reducer
011-PZV-0024
-
-
N
-
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
NFS
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
101CH4S
10"-GAS-011033002-101CH4S-N
011-SP-0030
-
-
N
-
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
NFS
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
033002
101CH4S
011-SP-0030
Reducer
-
-
N
-
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
NFS
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
011
033002
101CH4S
Reducer
011-PZV-0025
-
-
N
-
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
NFS
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
GAS
011
033002
101CH4S
10"-GAS-011033002-101CH4S-N
2"-GAS-011033002-101CH4S-N
-
-
N
-
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
NFS
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
2"
GAS
011
033002
101CH4S
2"-GAS-011033002-101CH4S-N
2"-LFL-011033301-101CH2F-N
-
-
N
-
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
NFS
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480086
1"
GAS
011
033002
101CH4S
10"-GAS-011033002-101CH4S-N 3/4"-LFL-011033306-101CH2F-N
-
-
N
-
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
NFS
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480086
1"
GAS
011
033002
101CH4S
10"-GAS-011033002-101CH4S-N
-
-
N
-
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
NFS
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
N
POTENTIAL
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C.
1"-LFL-011033306-101CH2F-N
if insulated M or Q SA-JER-DS011-TRJR-480086
-
GAS
011
033601
101CH4S
011-D-0008
TRIM
-
-
N
-
-
-
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480089
6"
GAS
011
034001
SA-JER-DS011-TRJR-480089
1"
GAS
011
034001
101CH4S
011-D-0009
SA-JER-DS011-TRJR-480090
S
60
H
40
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
3.50
-1.00
155.00
100.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
101CH4S
6"-GAS-011034001-101CH4S-S
011-PT-0083
S
60
H
25
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
3.50
-1.00
155.00
100.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480090
6"
GAS
011
034001
SA-JER-DS011-TRJR-480090
1"
GAS
011
034001
NOTE 6
101CH4S
SA-JER-DS011-TRJR-480089
011-D-0016
S
60
H
40
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
3.50
-1.00
155.00
100.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
101CH4S
6"-GAS-011034001-101CH4S-S
Blind flange
S
60
H
25
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
3.50
-1.00
155.00
100.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480090
6"
GAS
011
NOTE 6
034002
101CH4S
011-D-0016
SA-JER-DS011-TRJR-480091
S
60.2
H
40
SOUR OFF GAS
Gas
-
0.20
50.00
-
-
3.50
-1.00
155.00
100.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480090
1"
GAS
NOTE 6
011
034002
101CH4S
6"-GAS-011034002-101CH4S-S
011-PT-0308
S
60.2
H
25
SOUR OFF GAS
Gas
-
0.20
50.00
-
-
3.50
-1.00
155.00
100.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480091
6"
NOTE 6
GAS
011
034002
101CH4S
SA-JER-DS011-TRJR-480090
Reducer
S
60.2
H
40
SOUR OFF GAS
Gas
-
0.20
50.00
-
-
3.50
-1.00
155.00
100.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480091
NOTE 6
1"
GAS
011
034002
101CH4S
6"-GAS-011034002-101CH4S-S
Blind flange
S
60.2
H
25
SOUR OFF GAS
Gas
-
0.20
50.00
-
-
3.50
-1.00
155.00
100.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480091
8"
GAS
011
034002
101CH4S
Reducer
8"-GAS-011035401-101CH4S-S
S
60.2
H
40
SOUR OFF GAS
Gas
-
0.20
50.00
-
-
3.50
-1.00
155.00
100.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
if NOT insulated B or Q
NOTE 6
SA-JER-DS011-TRJR-480090
6"
GAS
011
034003
101CH4S
011-D-0016
011-SP-0031
-
-
N
-
SOUR OFF GAS
Gas
-
0.20
50.00
-
-
3.50
-1.00
90.00
100.00
-
H
5.25
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C NOTES 6, 10
SA-JER-DS011-TRJR-480090
6"
GAS
011
034003
101CH4S
011-SP-0031
Reducer
-
-
N
-
SOUR OFF GAS
Gas
-
0.20
50.00
-
-
3.50
-1.00
90.00
100.00
-
H
5.25
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C NOTE 10
SA-JER-DS011-TRJR-480090
2"
GAS
011
034003
101CH4S
Reducer
011-PZV-0048
-
-
N
-
SOUR OFF GAS
Gas
-
0.20
50.00
-
-
3.50
-1.00
90.00
100.00
-
H
5.25
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C NOTE 10
SA-JER-DS011-TRJR-480090
6"
GAS
011
034003
101CH4S
6"-GAS-011034003-101CH4S-N
011-SP-0031
-
-
N
-
SOUR OFF GAS
Gas
-
0.20
50.00
-
-
3.50
-1.00
90.00
100.00
-
H
5.25
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C NOTES 6,10
SA-JER-DS011-TRJR-480090
6"
GAS
011
034003
101CH4S
011-SP-0031
Reducer
-
-
N
-
SOUR OFF GAS
Gas
-
0.20
50.00
-
-
3.50
-1.00
90.00
100.00
-
H
5.25
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480090
2"
GAS
011
034003
101CH4S
Reducer
011-PZV-0055
-
-
N
-
SOUR OFF GAS
Gas
-
0.20
50.00
-
-
3.50
-1.00
90.00
100.00
-
H
5.25
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-380001
MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C NOTE 10
Page 76 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
-
-
N
-
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
SOUR OFF GAS
Gas
-
0.20
50.00
-
-
3.50
-1.00
SA-JER-DS011-TRJR-480090
2"
GAS
011
034003
101CH4S
6"-GAS-011034003-101CH4S-N
2"-GAS-011034003-101CH4S-N
SA-JER-DS011-TRJR-480090
2"
GAS
011
034003
101CH4S
2"-GAS-011034003-101CH4S-N
2"-LFL-011034307-101CH2F-N
-
-
N
-
SOUR OFF GAS
Gas
-
0.20
50.00
-
-
3.50
SA-JER-DS011-TRJR-480089
6"
GAS
011
034004
101CH4S
6"-GAS-011034001-101CH4S-S
SA-JER-DS011-TRJR-480094
S
60
H
40
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
3.50
SA-JER-DS011-TRJR-480089
1"
GAS
011
034004
101CH4S
6"-GAS-011034004-101CH4S-S
Blind flange
S
60
H
25
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
SA-JER-DS011-TRJR-480094
6"
GAS
011
034004
101CH4S
SA-JER-DS011-TRJR-480089
6"-GAS-011036003-101CH4S-S
S
60
H
40
SOUR OFF GAS
Gas
-
0.30
50.00
-
SA-JER-DS011-TRJR-480090
1"
GAS
011
034007
101CH4S
4"-GAS-011036006-101CH4S-N
1"-LFL-011034301-101CH2F-N
S
49.6
H
25
SOUR OFF GAS
Gas
-
2.00
41.00
SA-JER-DS011-TRJR-480090
1"
GAS
011
034007
101CH4S
1"-GAS-011034007-101CH4S-S
Blind flange
S
49.6
H
25
SOUR OFF GAS
Gas
-
2.00
SA-JER-DS011-TRJR-480090
1"
GAS
011
034012
101CH4S
011-LG-0098
1"-LFL-011034305-101CH2F-N
-
-
N
-
SOUR OFF GAS
Gas
-
SA-JER-DS011-TRJR-480089
3/4"
GAS
011
034013
101CH4S
011-LG-0061
Reducer
-
-
N
-
SOUR OFF GAS
Gas
SA-JER-DS011-TRJR-480089
1"
GAS
011
034013
101CH4S
Reducer
1"-LFL-011034306-101CH2F-N
-
-
N
-
SOUR OFF GAS
Gas
SA-JER-DS011-TRJR-480091
2"
GAS
011
034014
101CH4S
2"-N2L-011035302-101CS1P-N
Insul Brk
-
-
N
-
NITROGEN
SA-JER-DS011-TRJR-480091
2"
GAS
011
034014
101CH4S
Insul Brk
011-K-0001
S
60.2
H
25
SA-JER-DS011-TRJR-480090
2"
GAS
011
034015
101CH4S
2"-FGS-011034301-101CS2P-S
6"-GAS-011034001-101CH4S-S
S
60
H
25
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
90.00
100.00
-
H
5.25
M
YES
-1.00
90.00
100.00
-
H
5.25
M
-1.00
155.00
100.00
-
H
5.25
M
3.50
-1.00
155.00
100.00
-
H
5.25
-
3.50
-1.00
155.00
100.00
-
H
-
-
4.00
155.00
-
41.00
-
-
4.00
155.00
0.30
50.00
-
-
3.50
-1.00
90.00
-
0.30
50.00
-
-
3.50
-1.00
-
0.30
50.00
-
-
3.50
-1.00
Gas
-
0.20
50.00
-
-
3.50
NITROGEN
Gas
-
0.20
50.00
-
-
SOUR OFF GAS
Gas
-
0.30
50.00
-
-
N
POTENTIAL
N
Y
N
N
-
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C NOTE 10
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
H
6.00
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
-
H
6.00
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
100.00
-
H
5.25
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
150.00
100.00
-
-
-
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
150.00
100.00
-
H
5.25
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
-1.00
155.00
100.00
-
H
5.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
3.50
-1.00
155.00
100.00
-
H
5.25
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
3.50
-1.00
155.00
100.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
if insulated M or Q
NOTE 6
N
POTENTIAL
N
Y
N
N
-
STEAM OUT CONDITION:0.5 BARA (HALF VACUUM) @ 150°C
N
POTENTIAL
N
Y
N
N
-
STEAM OUT CONDITION:0.5 BARA (HALF VACUUM) @ 150°C
N
POTENTIAL
N
Y
N
N
-
STEAM OUT CONDITION:0.5 BARA (HALF VACUUM) @ 150°C
N
POTENTIAL
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
POTENTIAL
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
POTENTIAL
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
POTENTIAL
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
POTENTIAL
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
POTENTIAL
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
POTENTIAL
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
POTENTIAL
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
POTENTIAL
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
POTENTIAL
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6.
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
NOTES 6,7
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6. NOTE 7.
M
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
6.00
M
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
6.00
M
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
6.00
M
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
H
6.00
M
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
-
H
6.00
M
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
150.00
-
H
6.00
M
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
150.00
150.00
-
H
6.00
M
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
-1.00
150.00
150.00
-
H
6.00
M
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
4.00
-1.00
150.00
150.00
-
H
6.00
M
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
4.00
-1.00
155.00
150.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
-
4.00
-1.00
150.00
150.00
-
H
6.00
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
-
-
4.00
-1.00
150.00
150.00
-
H
6.00
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
122.00
-
-
4.00
-1.00
150.00
150.00
-
H
6.00
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
H
6.00
M
YES
M
N
POTENTIAL
N
Y
N
N
-
THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE.
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
H
6.00
M
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6.
-
0.20
50.00
-
-
3.50
-1.00
155.00
100.00
-
H
5.25
M
By Vendor
By Vendor
N
POTENTIAL
N
Y
N
N
By Vendor
NOTE 6
Gas
-
0.20
50.00
-
-
3.50
-1.00
155.00
100.00
-
H
5.25
M
By Vendor
By Vendor
N
POTENTIAL
N
Y
N
N
By Vendor
NOTE 6
SOUR OFF GAS
Gas
-
0.20
50.00
-
-
3.50
-1.00
155.00
100.00
-
H
5.25
M
By Vendor
By Vendor
N
POTENTIAL
N
Y
N
N
By Vendor
NOTE 6
25
SOUR OFF GAS
Gas
-
0.20
50.00
-
-
3.50
-1.00
155.00
100.00
-
H
5.25
M
By Vendor
By Vendor
N
POTENTIAL
N
Y
N
N
By Vendor
NOTE 6
H
40
SOUR OFF GAS
Gas
-
0.20
50.00
-
-
3.50
-1.00
155.00
100.00
-
H
5.25
M
By Vendor
By Vendor
N
POTENTIAL
N
Y
N
N
By Vendor
NOTE 6
H
25
SOUR OFF GAS
Gas
-
0.20
50.00
-
-
3.50
-1.00
155.00
100.00
-
H
5.25
M
By Vendor
By Vendor
N
POTENTIAL
N
Y
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480089
-
GAS
011
034601
101CH4S
011-D-0009
TRIM
-
-
H
-
-
-
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
Visual Test
0.00
M
YES
SA-JER-DS011-TRJR-480089
2"
GAS
011
034601
101CH4S
011-D-0009
Blind flange
-
-
H
25
-
-
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
M
YES
SA-JER-DS011-TRJR-480089
2"
GAS
011
034601
101CH4S
011-D-0009
011-PI-0084
-
-
H
25
-
-
-
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
M
YES
SA-JER-DS011-TRJR-480090
-
GAS
011
034602
101CH4S
011-D-0016
TRIM
-
-
P
-
-
-
-
0.30
50.00
-
-
3.50
-1.00
90.00
100.00
-
Visual Test
0.00
M
YES
SA-JER-DS011-TRJR-480090
2"
GAS
011
034602
101CH4S
011-D-0016
Blind flange
-
-
P
25
-
-
-
0.30
50.00
-
-
3.50
-1.00
90.00
100.00
-
H
5.25
M
YES
SA-JER-DS011-TRJR-480090
-
GAS
011
034603
103CH4S
011-D-0016
TRIM
-
-
P
-
-
-
-
0.30
50.00
-
-
3.50
-1.00
90.00
100.00
-
Visual Test
0.00
M
YES
SA-JER-DS011-TRJR-480090
2"
GAS
011
034603
103CH4S
011-D-0016
011-LT-0096
-
-
P
25
-
-
-
0.30
50.00
-
-
3.50
-1.00
90.00
100.00
-
H
5.25
M
YES
SA-JER-DS011-TRJR-480090
2"
GAS
011
034603
103CH4S
011-D-0016
011-LT-0097
-
-
P
25
-
-
-
0.30
50.00
-
-
3.50
-1.00
90.00
100.00
-
H
5.25
M
YES
SA-JER-DS011-TRJR-480090
2"
GAS
011
034603
103CH4S
011-D-0016
011-LT-0096
-
-
P
25
-
-
-
0.30
50.00
-
-
3.50
-1.00
90.00
100.00
-
H
5.25
M
YES
SA-JER-DS011-TRJR-480090
2"
GAS
011
034603
103CH4S
011-D-0016
011-LT-0097
-
-
P
25
-
-
-
0.30
50.00
-
-
3.50
-1.00
90.00
100.00
-
H
5.25
M
YES
SA-JER-DS011-TRJR-480090
2"
GAS
011
034603
103CH4S
011-D-0016
011-LG-0098
-
-
P
25
-
-
-
0.30
50.00
-
-
3.50
-1.00
90.00
100.00
-
H
5.25
M
YES
SA-JER-DS011-TRJR-480090
2"
GAS
011
034603
103CH4S
011-D-0016
011-PI-0309
-
-
P
25
-
-
-
0.30
50.00
-
-
3.50
-1.00
90.00
100.00
-
H
5.25
M
YES
SA-JER-DS011-TRJR-480090
2"
GAS
011
034603
103CH4S
011-D-0016
011-LG-0098
-
-
P
25
-
-
-
0.30
50.00
-
-
3.50
-1.00
90.00
100.00
-
H
5.25
M
YES
SA-JER-DS011-TRJR-480091
4"
GAS
011
035001
101CH4S
4"-GAS-011035404-101CH4S-P
SA-JER-DS011-TRJR-480092
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
H
6.00
M
YES
SA-JER-DS011-TRJR-480091
1"
GAS
011
035001
101CH4S
4"-GAS-011035001-101CH4S-P
Blind flange
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
H
6.00
M
YES
SA-JER-DS011-TRJR-480092
4"
GAS
011
035001
101CH4S
SA-JER-DS011-TRJR-480091
011-E-0036
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
H
6.00
M
YES
SA-JER-DS011-TRJR-480092
4"
GAS
011
035002
101CH4S
011-E-0036
SA-JER-DS011-TRJR-480093
-
-
N
-
SOUR OFF GAS
Liquid/Gas Mixture
6
2.10
41.50
-
-
4.00
-
H
6.00
M
SA-JER-DS011-TRJR-480093
4"
GAS
011
035002
101CH4S
SA-JER-DS011-TRJR-480092
011-D-0017
-
-
N
-
SOUR OFF GAS
Liquid/Gas Mixture
6
2.10
41.50
-
-
4.00
-
H
6.00
SA-JER-DS011-TRJR-480091
4"
GAS
011
035003
101CH4S
4"-GAS-011035409-101CH4S-P
4"-GAS-011035003-101CH4S-P
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
H
6.00
SA-JER-DS011-TRJR-480091
4"
GAS
011
035003
101CH4S
4"-GAS-011035003-101CH4S-P
4"-LFL-011035303-101CH2F-N
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
H
SA-JER-DS011-TRJR-480091
4"
GAS
011
035005
101CH4S
4"-GAS-011035003-101CH4S-P
011-SP-0040
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
H
SA-JER-DS011-TRJR-480091
4"
GAS
011
035005
101CH4S
011-SP-0040
Reducer
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
H
SA-JER-DS011-TRJR-480091
1"
GAS
011
035005
101CH4S
4"-GAS-011035005-101CH4S-P
Blind flange
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
SA-JER-DS011-TRJR-480091
2"
GAS
011
035005
101CH4S
Reducer
011-PZV-0550
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
SA-JER-DS011-TRJR-480091
4"
GAS
011
035005
101CH4S
4"-GAS-011035005-101CH4S-P
011-SP-0040
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
SA-JER-DS011-TRJR-480091
4"
GAS
011
035005
101CH4S
011-SP-0040
Reducer
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
SA-JER-DS011-TRJR-480091
1"
GAS
011
035005
101CH4S
4"-GAS-011035005-101CH4S-P
Blind flange
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
SA-JER-DS011-TRJR-480091
2"
GAS
011
035005
101CH4S
Reducer
011-PZV-0551
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
SA-JER-DS011-TRJR-480091
1"
GAS
011
035007
101CH4S
011-K-0001
Insul Brk
S
60.2
H
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
SA-JER-DS011-TRJR-480091
1"
GAS
011
035007
101CH4S
Insul Brk
Reducer
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
SA-JER-DS011-TRJR-480091
1"
GAS
011
035007
101CH4S
1"-GAS-011035007-101CH4S-P
Blind flange
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
SA-JER-DS011-TRJR-480091
2"
GAS
011
035007
101CH4S
Reducer
2"-CLD-011035301-101CH2S-P
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
SA-JER-DS011-TRJR-480274
1"
GAS
011
035008
101CH4S
4"-VTG-011035001-101CH4S-P
SAMPLE COOLER
-
-
P
25
SOUR OFF GAS
Gas
-
SA-JER-DS011-TRJR-480091
1"
GAS
011
035008
101CH4S
4"-GAS-011035001-101CH4S-P
011-SC-0025
-
-
P
25
SOUR OFF GAS
Gas
SA-JER-DS011-TRJR-480091
8"
GAS
011
035401
101CH4S
8"-GAS-011034002-101CH4S-S
011-S-0006
S
60.2
H
40
SOUR OFF GAS
Gas
SA-JER-DS011-TRJR-480091
1"
GAS
011
035401
101CH4S
8"-GAS-011035401-101CH4S-S
011-PT-0550
S
60.2
H
25
SOUR OFF GAS
SA-JER-DS011-TRJR-480091
2"
GAS
011
035401
101CH4S
8"-GAS-011035401-101CH4S-S
011-TT-0550
S
60.2
H
25
SA-JER-DS011-TRJR-480091
1"
GAS
011
035401
101CH4S
8"-GAS-011035401-101CH4S-S
011-PT-0551-A
S
60.2
H
SA-JER-DS011-TRJR-480091
8"
GAS
011
035401
101CH4S
011-S-0006
011-Y-0011
S
60.2
SA-JER-DS011-TRJR-480091
1"
GAS
011
035401
101CH4S
8"-GAS-011035401-101CH4S-S
011-PDT-0552
S
60.2
SA-JER-DS011-TRJR-380001
MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C NOTES 6, 10
A or Q
105.00 105.00
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
Page 77 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
DESIGN CONDITIONS
ALTERNATE CONDITIONS PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
(ºC)
TEST CONDITIONS
MEDIUM (NOTE 5)
PRESS. (BARG)
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6)
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480091
8"
GAS
011
035402
101CH4S
011-Y-0011
011-K-0001
S
60.2
H
40
SOUR OFF GAS
Gas
-
0.20
50.00
-
-
3.50
-1.00
155.00
100.00
-
H
5.25
M
By Vendor
By Vendor
N
POTENTIAL
N
Y
N
N
By Vendor
SA-JER-DS011-TRJR-480091
5"
GAS
011
035403
101CH4S
011-K-0001
Reducer
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
H
6.00
M
By Vendor
By Vendor
N
POTENTIAL
N
Y
N
N
By Vendor
SA-JER-DS011-TRJR-480091
4"
GAS
011
035403
101CH4S
Reducer
011-Y-0012
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
H
6.00
M
By Vendor
By Vendor
N
POTENTIAL
N
Y
N
N
By Vendor
SA-JER-DS011-TRJR-480091
4"
GAS
011
035404
101CH4S
011-Y-0012
4"-GAS-011035404-101CH4S-P
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
H
6.00
M
By Vendor
By Vendor
N
POTENTIAL
N
Y
N
N
By Vendor
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
SA-JER-DS011-TRJR-480091
1"
GAS
011
035404
101CH4S
4"-GAS-011035404-101CH4S-P
011-PDT-0552
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
H
6.00
M
By Vendor
By Vendor
N
POTENTIAL
N
Y
N
N
By Vendor
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
SA-JER-DS011-TRJR-480091
2"
GAS
011
035404
101CH4S
4"-GAS-011035404-101CH4S-P
011-TT-0551
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
H
6.00
M
By Vendor
By Vendor
N
POTENTIAL
N
Y
N
N
By Vendor
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
SA-JER-DS011-TRJR-480091
1"
GAS
011
035404
101CH4S
4"-GAS-011035404-101CH4S-P
011-PT-0551-B
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
H
6.00
M
By Vendor
By Vendor
N
POTENTIAL
N
Y
N
N
By Vendor
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
SA-JER-DS011-TRJR-480091
1"
GAS
011
035404
101CH4S
4"-GAS-011035404-101CH4S-P
011-PT-0553
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
H
6.00
M
By Vendor
By Vendor
N
POTENTIAL
N
Y
N
N
By Vendor
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
SA-JER-DS011-TRJR-480091
2"
GAS
011
035404
101CH4S
4"-GAS-011035404-101CH4S-P
011-TT-0552
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
H
6.00
M
By Vendor
By Vendor
N
POTENTIAL
N
Y
N
N
By Vendor
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
SA-JER-DS011-TRJR-480091
4"
GAS
011
035404
101CH4S
4"-GAS-011035404-101CH4S-P
4"-GAS-011035001-101CH4S-P
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
H
6.00
M
By Vendor
By Vendor
N
POTENTIAL
N
Y
N
N
By Vendor
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
SA-JER-DS011-TRJR-480091
2"
GAS
011
035405
101CH4S
011-K-0001
8"-GAS-011035401-101CH4S-S
S
60.2
H
25
NITROGEN
Gas
-
0.20
50.00
-
-
3.50
-1.00
155.00
100.00
-
H
5.25
M
By Vendor
By Vendor
N
POTENTIAL
N
N
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480091
2"
GAS
011
035406
101CH4S
4"-GAS-011035404-101CH4S-P
2"-LFL-011035302-101CH2F-N
-
-
P
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480091
2"
GAS
011
035408
101CH4S
8"-GAS-011035401-101CH4S-S
2"-LFL-011035309-101CH2F-N
S
60.2
H
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
155.00
120.00
-
H
5.25
M
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480091
4"
GAS
011
035409
101CH4S
4"-GAS-011035404-101CH4S-P
4"-GAS-011035003-101CH4S-P
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
150.00
-
H
6.00
M
By Vendor
By Vendor
N
POTENTIAL
N
Y
N
N
By Vendor
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
SA-JER-DS011-TRJR-480093
4"
GAS
011
036001
101CH4S
011-D-0017
SA-JER-DS011-TRJR-480094
-
N
SOUR OFF GAS
Gas
-
2.00
41.00
-
-
4.00
105.00
-
H
6.00
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
4"
GAS
011
036001
101CH4S
SA-JER-DS011-TRJR-480093
011-C-0007
-
-
N
-
SOUR OFF GAS
Gas
-
2.00
41.00
-
-
4.00
105.00
-
H
6.00
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
4"
GAS
011
036003
101CH4S
011-C-0007
Reducer
S
60
H
25
SWEET OFF-GAS
Gas
-
1.70
65.00
-
-
4.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
1/2"
GAS
011
036003
101CH4S
011-FE-0068
011-FT-0068
-
60
H
25
SWEET OFF-GAS
Gas
-
1.70
65.00
-
-
4.00
155.00
-
-
-
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
2"
GAS
011
036003
101CH4S
4"-GAS-011036003-101CH4S-S
011-TT-0213
S
60
H
25
SWEET OFF-GAS
Gas
-
1.70
65.00
-
-
4.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
1/2"
GAS
011
036003
101CH4S
011-FE-0068
011-FT-0068
-
60
H
25
SWEET OFF-GAS
Gas
-
1.70
65.00
-
-
4.00
155.00
-
-
-
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
1"
GAS
011
036003
101CH4S
4"-GAS-011036003-101CH4S-S
011-PT-0113
-
60
H
25
SWEET OFF-GAS
Gas
-
1.70
65.00
-
-
4.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
4"
GAS
011
036003
101CH4S
4"-GAS-011036003-101CH4S-S
Reducer
S
60
H
25
SWEET OFF-GAS
Gas
-
1.70
65.00
-
-
4.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
2"
GAS
011
036003
101CH4S
Reducer
2"-GAS-011036003-101CH4S-S
S
60
H
25
SWEET OFF-GAS
Gas
-
1.70
65.00
-
-
4.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
1"
GAS
011
036003
101CH4S
4"-GAS-011036003-101CH4S-S
011-PT-0112
-
60
H
25
SWEET OFF-GAS
Gas
-
1.70
65.00
-
-
4.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
2"
GAS
011
036003
101CH4S
Reducer
Reducer
S
60
H
25
SWEET OFF-GAS
Gas
-
1.70
65.00
-
-
4.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
4"
GAS
011
036003
101CH4S
Reducer
4"-GAS-011036003-101CH4S-S
S
60
H
25
SWEET OFF-GAS
Gas
-
1.70
65.00
-
-
4.00
155.00
-
H
6.00
M
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
4"
GAS
011
036003
101CH4S
4"-GAS-011036003-101CH4S-S
Reducer
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
155.00
-
H
6.00
M
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
1"
GAS
011
036003
101CH4S
4"-GAS-011036003-101CH4S-S
Blind flange
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
155.00
-
H
6.00
M
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
1"
GAS
011
036003
101CH4S
4"-GAS-011036003-101CH4S-S
011-PT-0456
-
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
155.00
-
H
6.00
M
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
1"
GAS
011
036003
101CH4S
4"-GAS-011036003-101CH4S-S
011-PT-0114
-
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
155.00
-
H
6.00
M
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
4"
GAS
011
036003
101CH4S
Reducer
4"-GAS-011036003-101CH4S-S
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
155.00
-
H
6.00
M
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
2"
GAS
011
036003
101CH4S
2"-GAS-011036003-101CH4S-S
Reducer
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
155.00
-
H
6.00
M
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
6"
GAS
011
036003
101CH4S
Reducer
Reducer
S
60
H
40
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
155.00
-
H
6.00
M
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
4"
GAS
011
036003
101CH4S
Reducer
011-ZV-0029
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
155.00
-
H
6.00
M
YES
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
1"
GAS
011
036003
101CH4S
4"-GAS-011036003-101CH4S-S
Blind flange
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
155.00
-
H
6.00
M
YES
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
6"
GAS
011
036004
101CH4S
011-ZV-0030
Reducer
S
60
H
40
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
1"
GAS
011
036004
101CH4S
6"-GAS-011036004-101CH4S-S
Blind flange
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
4"
GAS
011
036004
101CH4S
Reducer
SA-JER-DS011-TRJR-480118
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480118
4"
GAS
011
036004
101CH4S
SA-JER-DS011-TRJR-480094
011-FA-0002-A
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480118
1"
GAS
011
036004
101CH4S
4"-GAS-011036004-101CH4S-S
Blind flange
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480118
1"
GAS
011
036004
101CH4S
4"-GAS-011036004-101CH4S-S
011-PDT-0223
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480118
1"
GAS
011
036004
101CH4S
4"-GAS-011036004-101CH4S-S
Blind flange
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480118
4"
GAS
011
036004
101CH4S
4"-GAS-011036004-101CH4S-S
011-FA-0002-B
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
6"
GAS
011
036004
101CH4S
6"-GAS-011036003-101CH4S-S
011-ZV-0030
S
60
H
40
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
155.00
-
H
6.00
M
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
6"
GAS
011
036005
101CH4S
6"-GAS-011036004-101CH4S-S
Reducer
S
60
H
40
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
4"
GAS
011
036005
101CH4S
Reducer
SA-JER-DS011-TRJR-480119
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
4"
GAS
011
036005
101CH4S
SA-JER-DS011-TRJR-480094
011-FA-0002-A
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
1"
GAS
011
036005
101CH4S
4"-GAS-011036005-101CH4S-S
Blind flange
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
4"
GAS
011
036005
101CH4S
4"-GAS-011036005-101CH4S-S
011-FA-0002-B
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
100.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
1"
GAS
011
036005
101CH4S
4"-GAS-011036005-101CH4S-S
011-PDT-0237
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
100.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
1"
GAS
011
036005
101CH4S
4"-GAS-011036005-101CH4S-S
Blind flange
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
155.00
SA-JER-DS011-TRJR-480093
4"
GAS
011
036006
101CH4S
4"-GAS-011036001-101CH4S-N
SA-JER-DS011-TRJR-480090
-
-
N
-
SOUR OFF GAS
Gas
-
2.00
41.00
-
-
4.00
SA-JER-DS011-TRJR-480090
4"
GAS
011
036006
101CH4S
SA-JER-DS011-TRJR-480093
Reducer
-
-
N
-
SWEET OFF-GAS
Gas
-
2.00
41.00
-
-
4.00
-1.00
105.00
SA-JER-DS011-TRJR-480090
3"
GAS
011
036006
101CH4S
Insul Brk
Reducer
S
49.6
H
25
SWEET OFF-GAS
Gas
-
2.00
41.00
-
-
4.00
-1.00
SA-JER-DS011-TRJR-480090
2"
GAS
011
036006
101CH4S
Reducer
2"-GAS-011036006-101CH4S-S
S
49.6
H
25
SWEET OFF-GAS
Gas
-
2.00
41.00
-
-
4.00
SA-JER-DS011-TRJR-480090
2"
GAS
011
036006
101CH4S
Reducer
Reducer
-
-
N
-
SWEET OFF-GAS
Gas
-
2.00
41.00
-
-
SA-JER-DS011-TRJR-480090
4"
GAS
011
036006
101CH4S
Reducer
4"-GAS-011036006-101CH4S-N
-
-
N
-
SWEET OFF-GAS
Gas
-
2.00
41.00
-
SA-JER-DS011-TRJR-480090
4"
GAS
011
036006
101CH4S
4"-GAS-011036006-101CH4S-N
6"-GAS-011034001-101CH4S-S
-
-
N
-
SWEET OFF-GAS
Gas
-
0.30
41.50
SA-JER-DS011-TRJR-480090
2"
GAS
011
036006
101CH4S
2"-GAS-011036006-101CH4S-S
Reducer
S
49.6
H
25
SWEET OFF-GAS
Gas
-
0.30
41.50
SA-JER-DS011-TRJR-480090
3"
GAS
011
036006
101CH4S
Reducer
Insul Brk
S
49.6
H
25
SWEET OFF-GAS
Gas
-
0.30
SA-JER-DS011-TRJR-480094
4"
GAS
011
036007
101CH4S
011-SP-0032
Reducer
-
-
P
25
SWEET OFF-GAS
Gas
-
SA-JER-DS011-TRJR-480094
1"
GAS
011
036007
101CH4S
4"-GAS-011036007-101CH4S-P
Blind flange
-
-
P
25
SWEET OFF-GAS
Gas
SA-JER-DS011-TRJR-480094
1-1/2"
GAS
011
036007
101CH4S
Reducer
011-PZV-0034
-
-
P
25
SWEET OFF-GAS
SA-JER-DS011-TRJR-480094
4"
GAS
011
036007
101CH4S
4"-GAS-011036007-101CH4S-P
011-SP-0032
-
-
P
25
SA-JER-DS011-TRJR-480094
4"
GAS
011
036007
101CH4S
011-SP-0032
Reducer
-
-
P
SA-JER-DS011-TRJR-480094
1"
GAS
011
036007
101CH4S
4"-GAS-011036007-101CH4S-P
Blind flange
-
-
SA-JER-DS011-TRJR-480094
1-1/2"
GAS
011
036007
101CH4S
Reducer
011-PZV-0033
-
SA-JER-DS011-TRJR-480094
2"
GAS
011
036007
101CH4S
4"-GAS-011036007-101CH4S-P
2"-GAS-011036007-101CH4S-P
SA-JER-DS011-TRJR-480094
4"
GAS
011
036007
101CH4S
011-C-0007
SA-JER-DS011-TRJR-480094
2"
GAS
011
036007
101CH4S
SA-JER-DS011-TRJR-480094
1"
GAS
011
036007
SA-JER-DS011-TRJR-480093
3/4"
GAS
011
SA-JER-DS011-TRJR-480093
1"
GAS
011
SA-JER-DS011-TRJR-480094
1"
GAS
011
SA-JER-DS011-TRJR-480094
1"
GAS
SA-JER-DS011-TRJR-480094
1"
SA-JER-DS011-TRJR-480273
-
-
NOTE 6 MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C, NOTE 6 MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C, NOTE 6
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
6.00
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
100.00
-
H
6.00
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
155.00
100.00
-
H
6.00
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
-1.00
155.00
100.00
-
H
6.00
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
4.00
-1.00
105.00
100.00
-
H
6.00
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
-
4.00
-1.00
105.00
100.00
-
H
6.00
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
-
-
3.50
-1.00
100.00
100.00
-
H
5.25
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
-
-
3.50
-1.00
155.00
100.00
-
H
5.25
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
41.50
-
-
3.50
-1.00
155.00
100.00
-
H
5.25
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
0.30
65.00
-
-
4.00
-0.50
100.00
120.00
-
H
6.00
NFS
YES
M
N
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 160°C NOTE 10
-
0.30
65.00
-
-
4.00
-0.50
100.00
120.00
-
H
6.00
NFS
YES
M
N
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 160°C NOTE 10
Gas
-
0.30
65.00
-
-
4.00
-0.50
100.00
120.00
-
H
6.00
NFS
YES
M
N
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 160°C NOTE 10
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-0.50
100.00
120.00
-
H
6.00
NFS
YES
M
N
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 160°C NOTE 6, 10
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-0.50
100.00
120.00
-
H
6.00
NFS
YES
M
N
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 160°C NOTE 10
P
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-0.50
100.00
120.00
-
H
6.00
NFS
YES
M
N
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 160°C NOTE 10
-
P
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-0.50
100.00
120.00
-
H
6.00
NFS
YES
M
N
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 160°C NOTE 10
-
-
P
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-0.50
100.00
120.00
-
H
6.00
NFS
YES
M
N
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 160°C NOTE 6, 10
011-SP-0032
-
-
P
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-0.50
100.00
120.00
-
H
6.00
NFS
YES
M
N
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 160°C NOTE 6, 10
2"-GAS-011036007-101CH4S-P
2"-LFL-011036301-101CH2F-N
-
-
P
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-0.50
100.00
120.00
-
H
6.00
NFS
YES
M
N
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 160°C NOTE 10
101CH4S
2"-GAS-011036007-101CH4S-P
Blind flange
-
-
P
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-0.50
100.00
120.00
-
H
6.00
NFS
YES
M
N
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 160°C NOTE 10
036008
101CH4S
011-LG-0071
Reducer
-
N
-
SOUR OFF GAS
Gas
-
2.00
40.00
-
-
4.00
105.00
-
-
-
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
036008
101CH4S
Reducer
1"-LFL-011036307-101CH2F-N
-
-
N
-
SOUR OFF GAS
Gas
-
2.00
40.00
-
-
4.00
105.00
-
H
6.00
M
YES
A or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
036011
101CH4S
4"-GAS-011036003-101CH4S-S
1"-LFL-011036303-101CH2F-N
S
60
H
25
SWEET OFF-GAS
Gas
-
1.70
65.00
-
-
4.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
011
036011
101CH4S
1"-GAS-011036011-101CH4S-S
Blind flange
S
60
H
25
SWEET OFF-GAS
Gas
-
1.70
65.00
-
-
4.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
GAS
011
036012
101CH4S
4"-GAS-011036003-101CH4S-S
011-SC-0030
S
60
H
25
SWEET OFF-GAS
Gas
-
1.70
65.00
-
-
4.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
1"
GAS
011
036012
101CH4S
4"-VTG-011036003-101CH4S-S
Reducer
S
60
H
25
SWEET OFF-GAS
Gas
-
1.70
65.00
-
-
4.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
1/2"
GAS
011
036012
101CH4S
Reducer
SAMPLE CYLINDER
S
60
H
25
SWEET OFF-GAS
Gas
-
1.70
65.00
-
-
4.00
155.00
-
-
-
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480094
1"
GAS
011
036013
101CH4S
011-SC-0030
4"-GAS-011036003-101CH4S-S
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
1"
GAS
011
036013
101CH4S
Reducer
4"-VTG-011036003-101CH4S-S
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
155.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
1/2"
GAS
011
036013
101CH4S
SAMPLE CYLINDER
Reducer
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
155.00
-
-
-
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-380001
-
105.00
Page 78 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7) if insulated M or Q
SA-JER-DS011-TRJR-480093
-
GAS
011
036601
101CH4S
011-D-0017
TRIM
-
-
N
-
-
-
-
2.00
40.00
-
-
4.00
105.00
-
Visual Test
0.00
M
YES
N
POTENTIAL
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
SA-JER-DS011-TRJR-480093
-
GAS
011
036602
103CH4S
011-D-0017
TRIM
-
-
N
-
-
-
-
2.00
40.00
-
-
4.00
105.00
-
Visual Test
0.00
M
YES
N
POTENTIAL
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
SA-JER-DS011-TRJR-480094
-
GAS
011
036603
101CH4S
011-C-0007
TRIM
-
-
H
-
-
-
-
2.00
65.00
-
-
4.00
100.00
-
Visual Test
0.00
NFS
YES
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
SA-JER-DS011-TRJR-480094
2"
GAS
011
036603
101CH4S
011-C-0007
Blind flange
-
-
H
25
-
-
-
2.00
65.00
-
-
4.00
100.00
-
H
6.00
NFS
YES
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
SA-JER-DS011-TRJR-480094
-
GAS
011
036604
103CH4S
011-C-0007
TRIM
-
-
H
-
-
-
-
2.00
65.00
-
-
4.00
100.00
-
Visual Test
0.00
NFS
YES
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
SA-JER-DS011-TRJR-480094
2"
GAS
011
036604
103CH4S
011-C-0007
011-PI-0116
-
-
H
25
-
-
-
2.00
65.00
-
-
4.00
-
H
6.00
NFS
YES
SA-JER-DS011-TRJR-480118
4"
GAS
011
048001
101CH4S
011-FA-0001-A/B
Header
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
100.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
M or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480118
1"
GAS
011
048001
101CH4S
4"-GAS-011048001-101CH4S-S
Blind flange
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
100.00
-
H
6.00
NFS
SA-JER-DS011-TRJR-480118
4"
GAS
011
048001
101CH4S
011-FA-0002-B
4"-GAS-011048001-101CH4S-S
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
100.00
-
H
6.00
NFS
NOTE 6
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
YES
M or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480118
1"
GAS
011
048001
101CH4S
4"-GAS-011048001-101CH4S-S
Blind flange
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
100.00
-
H
6.00
NOTE 6
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480118
1"
GAS
011
048001
101CH4S
4"-GAS-011048001-101CH4S-S
011-PDT-0223
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
100.00
-
H
NOTE 6
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480118
1"
GAS
011
048001
101CH4S
4"-GAS-011048001-101CH4S-S
011-PT-0207
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
100.00
-
NOTE 6
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480118
2"
GAS
011
048001
101CH4S
4"-GAS-011048001-101CH4S-S
Reducer
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
100.00
NOTE 6
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480118
1"
GAS
011
048001
101CH4S
2"-GAS-011048001-101CH4S-S
011-PI-0206
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
155.00
NOTE 6
100.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480118
1-1/2"
GAS
011
048001
101CH4S
Reducer
011-F-0002
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
SA-JER-DS011-TRJR-480119
4"
GAS
011
049001
101CH4S
011-FA-0002-A/B
HEADER
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
-1.00
NOTE 6
155.00
100.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
155.00
100.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480119
1"
GAS
011
049001
101CH4S
4"-GAS-011049001-101CH4S-S
011-PDT-0237
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
4.00
NOTE 6
-1.00
155.00
100.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480119
4"
GAS
011
049001
101CH4S
011-FA-0002-B
4"-GAS-011049001-101CH4S-S
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
-
NOTE 6
4.00
-1.00
155.00
100.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480119
1"
GAS
011
049001
101CH4S
4"-GAS-011049001-101CH4S-S
Blind flange
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
-
NOTE 6
-
4.00
-1.00
155.00
100.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480119
1"
GAS
011
049001
101CH4S
4"-GAS-011049001-101CH4S-S
Blind flange
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
65.00
NOTE 6
-
-
4.00
-1.00
155.00
100.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480119
1"
GAS
011
049001
101CH4S
4"-GAS-011049001-101CH4S-S
011-PT-0238
S
60
H
25
SWEET OFF-GAS
Gas
-
0.30
NOTE 6
65.00
-
-
4.00
-1.00
155.00
100.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480119
2"
GAS
011
049001
101CH4S
4"-GAS-011049001-101CH4S-S
Reducer
S
60
H
25
SWEET OFF-GAS
Gas
-
SA-JER-DS011-TRJR-480119
1"
GAS
011
049001
101CH4S
2"-GAS-011049001-101CH4S-S
011-PI-0239
S
60
H
25
SWEET OFF-GAS
Gas
-
NOTE 6
0.30
65.00
-
-
4.00
-1.00
155.00
100.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
0.30
65.00
-
-
4.00
-1.00
155.00
100.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480119
1-1/2"
GAS
011
049001
101CH4S
Reducer
011-F-0002
S
60
H
25
SWEET OFF-GAS
Gas
NOTE 6
-
0.30
65.00
-
-
4.00
-1.00
155.00
100.00
-
H
6.00
NFS
YES
M or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480122
10"
GAS
011
052001
101CS2P
011-D-0010
ATM
-
-
P
25
AIR
NOTE 6
Gas
-
0.00
105.00
-
-
3.50
150.00
-
Visual Test
0.00
NFS
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480125
3"
GAS
011
053301
101SC1P
011-D-0031
DRIP PAN
-
-
N
-
NOTE 6
AIR
Gas
-
0.00
27.00
-
-
0.00
55.00
-
H
0.00
NFS
NO
E
Y
POTENTIAL
N
N
N
N
By Vendor
SA-JER-DS011-TRJR-480126
2"
GAS
011
054301
101SC1P
011-D-0032
2"-GAS-011054301-101SC1P-N
-
-
N
NOTE 6
-
AIR
Gas
-
0.00
27.00
-
-
0.00
55.00
-
H
0.00
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
SA-JER-DS011-TRJR-480126
2"
GAS
011
054301
101SC1P
2"-GAS-011054301-101SC1P-N
DRIP PAN
-
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
55.00
-
H
0.00
NFS
NO
E
N
N
N
N
N
N
By Vendor
SA-JER-DS011-TRJR-480127
2"
GAS
011
054302
101SC1P
011-D-0033
DRIP PAN
-
SA-JER-DS011-TRJR-480128
2"
GAS
011
054303
101SD0P
011-D-0034
DRIP PAN
-
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
55.00
-
H
0.00
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
55.00
-
H
0.00
NFS
NO
E
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480202
4"
GAS
011
071301
101CS1P
HEADER
ATM
-
-
-
P
25
FLUID AIR
Gas
-
0.00
27.00
-
-
0.00
128.00
-
Visual Test
0.00
NFS
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480202
2"
GAS
011
071302
101CS1P
ATM
-
6"-OLW-011071306-101CS1P-P
-
-
P
25
FLUID AIR
Gas
-
0.00
27.00
-
-
0.00
128.00
-
H
0.00
NFS
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480202
3"
GAS
011
071303
101CS1P
-
HEADER
ATM
-
-
P
25
FLUID AIR
Gas
-
0.00
27.00
-
-
0.00
128.00
-
Visual Test
0.00
NFS
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480202
2"
GAS
011
071304
-
101CS1P
4"-OLW-011071307-101CS1P-P
ATM
-
-
P
25
FLUID AIR
Gas
-
0.00
27.00
-
-
0.00
128.00
-
Visual Test
0.00
NFS
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480274
3/4"
GAS
011
200002
-
101CH4S
SAMPLE COOLER
Reducer
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
-
-
M
YES
M
N
POTENTIAL
N
Y
N
N
-
-
Reducer
Reducer
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
H
6.00
M
YES
M
N
POTENTIAL
N
Y
N
N
-
-
3/4"-LFL-011200303-101CH2F-N
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
-
-
M
YES
M
N
POTENTIAL
N
Y
N
N
-
-
100.00
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
SA-JER-DS011-TRJR-480274
4"
GAS
011
200002
101CH4S
SA-JER-DS011-TRJR-480274
3/4"
GAS
011
200002
101CH4S
SA-JER-DS011-TRJR-480274
3/4"
GAS
011
200002
101CH4S 3/4"-GAS-011200002-101CH4S-P
Plug
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
-
-
M
YES
M
N
POTENTIAL
N
Y
N
N
-
-
SA-JER-DS011-TRJR-480274
1/2"
GAS
011
200002
101CH4S 3/4"-GAS-011200002-101CH4S-P
Reducer
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
-
-
M
YES
M
N
POTENTIAL
N
Y
N
N
-
-
SA-JER-DS011-TRJR-480274
1/4"
GAS
011
200002
101CH4S
Reducer
SAMPLE CYLINDER
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
-
-
M
YES
M
N
POTENTIAL
N
Y
N
N
-
-
SA-JER-DS011-TRJR-480274
1/4"
GAS
011
200002
101CH4S
SAMPLE CYLINDER
Reducer
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
-
-
M
YES
M
N
POTENTIAL
N
Y
N
N
-
-
SA-JER-DS011-TRJR-480274
1/2"
GAS
011
200002
101CH4S
Reducer
3/4"-GAS-011200002-101CH4S-P
-
-
P
25
SOUR OFF GAS
Gas
-
2.50
122.00
-
-
4.00
-1.00
150.00
150.00
-
-
-
M
YES
M
N
POTENTIAL
N
Y
N
N
-
-
SA-JER-DS011-TRJR-480289
1"
GAS
011
230301
101CS1P
Blind flange
ATM
-
-
N
-
VENT GAS
Gas
-
0.00
27.00
-
-
0.00
150.00
-
Visual Test
0.00
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480003
6"
HFO
011
001001
103CS1P
011-E-0002
SA-JER-DS011-TRJR-480061
-
-
P
25
HAGO
Liquid
827
11.44
95.00
-
-
20.00
205.00
-
H
30.02
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
2"
HFO
011
001001
103CS1P
6"-HFO-011001001-103CS1P-P
011-TT-0006
-
-
P
25
HAGO
Liquid
827
11.44
95.00
-
-
20.00
205.00
-
H
30.02
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480061
6"
HFO
011
001001
103CS1P
SA-JER-DS011-TRJR-480003
011-A-0004
-
-
P
25
HAGO
Liquid
827
11.44
95.00
-
-
20.00
205.00
-
H
30.02
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480061
6"
HFO
011
001001
103CS1P
6"-HFO-011001001-103CS1P-P
011-A-0004
-
-
P
25
HAGO
Liquid
827
11.44
95.00
-
-
20.00
205.00
-
H
30.02
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
3/4"
HFO
011
001002
103CS1P
6"-HFO-011001001-103CS1P-P
Reducer
-
-
P
25
HAGO
Liquid
827
11.44
95.00
-
-
20.00
205.00
-
H
30.02
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
3/4"
HFO
011
001002
103CS1P 3/4"-HFO-011001002-103CS1P-P
Plug
-
-
P
25
HAGO
Liquid
827
11.44
95.00
-
-
20.00
205.00
-
H
30.02
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
2"
HFO
011
001002
103CS1P
2"-CLD-011001312-101CH2S-P
-
-
P
25
HAGO
Liquid
827
11.44
95.00
-
-
20.00
205.00
-
H
30.02
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
6"
HFO
011
005001
103CS1P
6"-HFO-011005004-103CL2P-H
SA-JER-DS011-TRJR-480003
-
-
H
50
HAGO
Liquid
787
12.12
160.00
-
-
20.00
325.00
-
H
34.89
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
4"
HFO
011
005001
103CS1P
4"-HFO-011009001-103CL2P-H
6"-HFO-011005001-103CS1P-H
-
-
H
50
HAGO
Liquid
787
12.12
160.00
-
-
20.00
325.00
-
H
34.89
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
HFO
011
005001
103CS1P
6"-HFO-011005001-103CS1P-H
011-TT-0030
-
-
H
40
HAGO
Liquid
787
12.12
160.00
-
-
20.00
325.00
-
H
34.89
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
HFO
011
005001
103CS1P
6"-HFO-011005001-103CS1P-H
011-TT-0388
-
-
H
40
HAGO
Liquid
787
12.12
160.00
-
-
20.00
325.00
-
H
34.89
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
6"
HFO
011
005001
103CS1P
6"-HFO-011005005-103CL2P-H
6"-HFO-011005001-103CS1P-H
-
-
H
50
HAGO
Liquid
787
12.12
160.00
-
-
20.00
325.00
-
H
34.89
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
6"
HFO
011
005001
103CS1P
SA-JER-DS011-TRJR-480010
011-E-0002
-
-
H
50
HAGO
Liquid
787
12.12
160.00
-
-
20.00
325.00
-
H
34.89
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
6"
HFO
011
005004
103CL2P
011-E-0009-A
6"-HFO-011005001-103CS1P-H
-
-
H
50
HAGO
Liquid
787
12.12
160.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
HFO
011
005004
103CL2P
6"-HFO-011005004-103CL2P-H
011-TI-0171
-
-
H
40
HAGO
Liquid
787
12.12
160.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
HFO
011
005004
103CL2P
2"-HFO-011005008-103CL2P-P
6"-HFO-011005004-103CL2P-H
-
-
H
40
HAGO
Liquid
787
12.12
160.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
HFO
011
005004
103CL2P
6"-HFO-011005004-103CL2P-H
2"-HFO-011005006-103CL2P-P
-
-
H
40
HAGO
Liquid
787
12.12
160.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
6"
HFO
011
005005
103CL2P
011-E-0009-B
6"-HFO-011005001-103CS1P-H
-
-
H
50
HAGO
Liquid
787
12.12
160.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
HFO
011
005005
103CL2P
6"-HFO-011005005-103CL2P-H
011-TI-0174
-
-
H
40
HAGO
Liquid
787
12.12
160.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
HFO
011
005005
103CL2P
6"-HFO-011005005-103CL2P-H
2"-HFO-011005007-103CL2P-P
-
-
H
40
HAGO
Liquid
787
12.12
160.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
HFO
011
005006
103CL2P
2"-HFO-011005004-103CL2P-H
2"-CLD-011005305-101CH2S-P
-
-
P
25
HAGO
Liquid
787
12.12
160.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
HFO
011
005006
103CL2P
2"-HFO-011005006-103CL2P-P
Blind flange
-
-
P
25
HAGO
Liquid
787
12.12
160.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
HFO
011
005007
103CL2P
2"-HFO-011005005-103CL2P-H
2"-CLD-011005306-101CH2S-P
-
-
P
25
HAGO
Liquid
787
12.12
160.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
HFO
011
005007
103CL2P
2"-HFO-011005007-103CL2P-P
Blind flange
-
-
P
25
HAGO
Liquid
787
12.12
160.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
HFO
011
005008
103CL2P
UC
2"-HFO-011005004-103CL2P-H
-
-
P
25
HAGO
Liquid
787
12.12
160.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@290 ºC.
SA-JER-DS011-TRJR-480010
3/4"
HFO
011
005008
103CL2P
2"-HFO-011005008-103CL2P-P
Blind flange
-
-
P
25
HAGO
Liquid
787
12.12
160.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@290 ºC.
SA-JER-DS011-TRJR-480010
2"
HFO
011
005009
103CL2P
UC
Insul Brk
-
-
P
25
HAGO
Liquid
787
12.12
160.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@290 ºC.
SA-JER-DS011-TRJR-480010
3/4"
HFO
011
005009
103CL2P
2"-HFO-011005009-103CL2P-P
Blind flange
-
-
P
25
HAGO
Liquid
787
12.12
160.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@290 ºC.
Reducer
Reducer
SA-JER-DS011-TRJR-480010
2"
HFO
011
005009
103CL2P
Insul Brk
6"-HFO-011005005-103CL2P-H
-
-
H
40
HAGO
Liquid
787
12.12
160.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@290 ºC.
SA-JER-DS011-TRJR-480010
3/4"
HFO
011
005010
103CL2P
6"-HFO-011009001-103CL2P-H
Insul Brk
-
-
H
40
HAGO
Liquid
690
13.18
255.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
3/4"
HFO
011
005010
103CL2P
Insul Brk
Reducer
-
-
P
40
HAGO
Liquid
690
13.18
255.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
3/4"
HFO
011
005010
103CL2P
3/4"-HFO-011005010-103CL2P-P
Blind flange
-
-
P
40
HAGO
Liquid
690
13.18
255.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
HFO
011
005010
103CL2P
Reducer
2"-CLD-011005312-101CH2S-P
-
-
P
40
HAGO
Liquid
690
13.18
255.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
3/4"
HFO
011
005011
103CL2P
6"-HFO-011009001-103CL2P-H
Insul Brk
-
-
H
40
HAGO
Liquid
690
13.18
255.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 79 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480010
3/4"
HFO
011
005011
103CL2P
Insul Brk
Reducer
-
-
P
40
HAGO
Liquid
690
13.18
255.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
3/4"
HFO
011
005011
103CL2P
3/4"-HFO-011005011-103CL2P-P
Blind flange
-
-
P
40
HAGO
Liquid
690
13.18
255.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
HFO
011
005011
103CL2P
Reducer
2"-CLD-011005311-101CH2S-P
-
-
P
40
HAGO
Liquid
690
13.18
255.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
12"
HFO
011
008001
103CS1P
011-E-0010-B
12"-HFO-011008001-103CS1P-S
S
31
H
65
HVGO
Liquid
857
12.14
160.00
-
-
33.10
210.00
-
H
49.93
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
12"
HFO
011
008001
103CS1P
12"-HFO-011008001-103CS1P-S
SA-JER-DS011-TRJR-480100
S
31
H
65
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
12"
HFO
011
008001
103CS1P
SA-JER-DS011-TRJR-480016
Reducer
S
31
H
65
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
8"
HFO
011
008001
103CS1P
Reducer
Reducer
S
31
H
65
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
2"-FLO-011038304-101CS1P-N
8"-HFO-011008001-103CS1P-S
S
31
H
40
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
31
H
40
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
2"
HFO
011
008001
103CS1P
SA-JER-DS011-TRJR-480100
3/4"
HFO
011
008001
103CS1P
8"-HFO-011008001-103CS1P-S
Blind flange
S
HVGO
Liquid
SA-JER-DS011-TRJR-480100
3/4"
HFO
011
008001
103CS1P
2"-HFO-011008001-103CS1P-S
Plug
S
31
H
40
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
10"
HFO
011
008001
103CS1P
Reducer
011-E-0030-A
S
31
H
65
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
2"
HFO
011
008001
103CS1P
10"-HFO-011008001-103CS1P-S
Blind flange
S
31
H
40
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
10"
HFO
011
008001
103CS1P
Reducer
10"-HFO-011008001-103CS1P-S
S
31
H
65
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
12"
HFO
011
008001
103CS1P
12"-HFO-011040120-103CS1P-S
Reducer
S
31
H
65
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
2"
HFO
011
008003
103CS1P
12"-HFO-011008001-103CS1P-S
2"-CLD-011008306-101CH2S-P
S
31
H
40
HVGO
Liquid
857
12.14
160.00
-
-
33.10
210.00
-
H
49.93
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
2"
HFO
011
008003
103CS1P
2"-HFO-011008003-103CS1P-S
Blind flange
S
31
H
40
HVGO
Liquid
857
12.14
160.00
-
-
33.10
210.00
-
H
49.93
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
12"
HFO
011
008016
103CS1P
12"-HFO-011013002-103CS1P-S 12"-HFO-011008001-103CS1P-S
S
31
H
100
HVGO
Liquid
831
13.95
207.00
-
-
30.00
290.00
-
H
49.90
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
2"
HFO
011
008017
103CS1P
12"-HFO-011013002-103CS1P-S
2"-CLD-011008305-101CH2S-P
S
31
H
50
HVGO
Liquid
831
13.95
207.00
-
-
33.10
290.00
-
H
55.06
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
2"
HFO
011
008017
103CS1P
2"-HFO-011008017-103CS1P-S
Blind flange
S
31
H
50
HVGO
Liquid
831
13.95
207.00
-
-
33.10
290.00
-
H
55.06
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
2"
HFO
011
008019
103CS1P
UC
Insul Brk
-
-
P
25
HVGO
Liquid
857
12.14
160.00
-
-
33.10
210.00
-
H
49.93
NFS
By Code
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@290ºC.
SA-JER-DS011-TRJR-480016
3/4"
HFO
011
008019
103CS1P
2"-HFO-011008019-103CS1P-P
Plug
-
-
P
25
HVGO
Liquid
857
12.14
160.00
-
-
33.10
210.00
-
H
49.93
NFS
By Code
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@290ºC.
SA-JER-DS011-TRJR-480016
2"
HFO
011
008019
103CS1P
Insul Brk
12"-HFO-011008001-103CS1P-S
S
31
H
40
HVGO
Liquid
857
12.14
160.00
-
-
33.10
210.00
-
H
49.93
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
N
POTENTIAL
N
N
N
N
-
NOTE 6
if insulated N or Q SA-JER-DS011-TRJR-480016
-
HFO
011
008601
106CS1P
TRIM
-
-
H
-
-
-
-
14.60
207.00
-
-
33.10
235.00
-
Visual Test
0.00
NFS
By Code
SA-JER-DS011-TRJR-480017
8"
HFO
011
009001
103CL2P
SA-JER-DS011-TRJR-480017
6"
HFO
011
009001
103CL2P
Reducer
SA-JER-DS011-TRJR-480017
6"
HFO
011
009001
103CL2P
011-PDT-0110
6"-HFO-011009001-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
690
13.18
255.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
-
-
H
100
HAGO
Liquid
690
13.18
255.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
H
100
HAGO
Liquid
690
13.18
255.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
6"
HFO
011
009001
103CL2P
SA-JER-DS011-TRJR-480017
NOTE 6
6"-HFO-011009001-103CL2P-H
-
-
H
100
HAGO
Liquid
690
13.18
255.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
4"
HFO
011
009001
103CL2P
NOTE 6
6"-HFO-011009001-103CL2P-H
4"-HFO-011005001-103CS1P-H
-
-
H
65
HAGO
Liquid
690
13.18
255.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
6"
HFO
011
009001
NOTE 6
103CL2P
6"-HFO-011009001-103CL2P-H
6"-HFO-011009001-103CL2P-H
-
-
H
100
HAGO
Liquid
690
13.18
255.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
6"
HFO
011
NOTE 6
009001
103CL2P
6"-HFO-011009001-103CL2P-H
011-E-0009-B
-
-
H
100
HAGO
Liquid
690
13.18
255.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
3/4"
HFO
SA-JER-DS011-TRJR-480010
2"
HFO
NOTE 6
011
009001
103CL2P
2"-HFO-011009001-103CL2P-P
Blind flange
-
-
H
40
HAGO
Liquid
690
13.18
255.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
011
009001
103CL2P
6"-HFO-011009001-103CL2P-H
Blind flange
-
-
H
65
HAGO
Liquid
690
13.18
255.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
2"
NOTE 6
HFO
011
009001
103CL2P
2"-FLO-011005304-101CS1P-N
Insul Brk
-
-
H
65
HAGO
Liquid
690
13.18
255.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480010
NOTE 6
2"
HFO
011
009001
103CL2P
Insul Brk
6"-HFO-011009001-103CL2P-H
-
-
H
65
HAGO
Liquid
690
13.18
255.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
3/4"
HFO
011
009001
103CL2P
2"-HFO-011009001-103CL2P-P
Blind flange
-
-
H
40
HAGO
Liquid
690
13.18
255.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
HFO
011
009001
103CL2P
Insul Brk
6"-HFO-011009001-103CL2P-H
-
-
H
65
HAGO
Liquid
690
13.18
255.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
HFO
011
009001
103CL2P
2"-FLO-011005303-101CS1P-N
Insul Brk
-
-
H
65
HAGO
Liquid
690
13.18
255.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
2"
HFO
011
009001
103CL2P
6"-HFO-011009001-103CL2P-H
Blind flange
-
-
H
65
HAGO
Liquid
690
13.18
255.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
6"
HFO
011
009001
103CL2P
6"-HFO-011009001-103CL2P-H
011-E-0009-A
-
-
H
100
HAGO
Liquid
690
13.18
255.00
-
-
38.50
325.00
-
H
69.03
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
6"
HFO
011
009002
103CL2P
6"-HFO-011024006-103CL2P-H
6"-HFO-011009002-103CL2P-H
-
-
H
100
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
6"
HFO
011
009002
103CL2P
6"-HFO-011009002-103CL2P-H
6"-HFO-011009002-103CL2P-H
-
-
H
100
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
6"
HFO
011
009002
103CL2P
6"-HFO-011009002-103CL2P-H
6"-HFO-011009001-103CL2P-H
-
-
H
100
HAGO
Liquid
690
13.18
255.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
6"
HFO
011
009002
103CL2P
6"-HFO-011009002-103CL2P-H
6"-HFO-011009002-103CL2P-H
-
-
H
100
HAGO
Liquid
690
13.18
255.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
3/4"
HFO
011
009003
103CL2P
6"-HFO-011009002-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
3/4"
HFO
011
009003
103CL2P
Insul Brk
Reducer
-
-
P
40
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
3/4"
HFO
011
009003
103CL2P
3/4"-HFO-011009003-103CL2P-P
Blind flange
-
-
P
40
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
2"
HFO
011
009003
103CL2P
Reducer
2"-CLD-011009303-101CH2S-P
-
-
P
50
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
3/4"
HFO
011
009003
103CL2P
6"-HFO-011009002-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
3/4"
HFO
011
009003
103CL2P
Insul Brk
3/4"-HFO-011009003-103CL2P-P
-
-
P
40
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
2"
HFO
011
009004
103CL2P
6"-HFO-011009001-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
690
13.18
255.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
2"
HFO
011
009004
103CL2P
Insul Brk
2"-CLD-011009307-101CH2S-P
-
-
P
40
HAGO
Liquid
690
13.18
255.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
2"-HFO-011009004-103CL2P-P
Blind flange
-
-
P
40
HAGO
Liquid
690
13.18
255.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
65
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
011-E-0010-A/B
011-E-0012-B
if NOT insulated C or Q
SA-JER-DS011-TRJR-480017
2"
HFO
011
009004
103CL2P
SA-JER-DS011-TRJR-480017
3/4"
HFO
011
009005
103CL2P
6"-HFO-011024006-103CL2P-H
Insul Brk
-
HAGO
Liquid
SA-JER-DS011-TRJR-480017
3/4"
HFO
011
009005
103CL2P
Insul Brk
Reducer
-
-
P
40
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
3/4"
HFO
011
009005
103CL2P
3/4"-HFO-011009005-103CL2P-P
Blind flange
-
-
P
40
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
2"
HFO
011
009005
103CL2P
Reducer
2"-CLD-011009308-101CH2S-P
-
-
P
50
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
2"
HFO
011
009006
103CL2P
UC
Insul Brk
-
-
P
50
HAGO
Liquid
690
13.50
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@ 290ºC.
SA-JER-DS011-TRJR-480017
3/4"
HFO
011
009006
103CL2P
2"-HFO-011009006-103CL2P-P
Blind flange
-
-
P
40
HAGO
Liquid
690
13.50
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@ 290ºC.
SA-JER-DS011-TRJR-480017
2"
HFO
011
009006
103CL2P
Insul Brk
6"-HFO-011024006-103CL2P-H
-
-
H
65
HAGO
Liquid
690
13.50
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@ 290ºC.
N
POTENTIAL
N
N
N
N
-
NOTE 6
if insulated N or Q SA-JER-DS011-TRJR-480017
-
HFO
011
009601
103CS1P
TRIM
-
-
SA-JER-DS011-TRJR-480019
10"
HFO
011
010101
103CL2P
011-E-0014-B
SA-JER-DS011-TRJR-480019
2"
HFO
011
010101
103CL2P
10"-HFO-011010101-103CL2P-S
SA-JER-DS011-TRJR-480019
-
HFO
011
010101
103CL2P
TRIM
011-E-0014-C
S
155
011-TI-0353
S
155
011-E-0014-A/B/C/D/E/F
-
-
SA-JER-DS011-TRJR-480019
10"
HFO
011
010102
103CL2P
011-E-0014-E
011-E-0014-F
S
155
SA-JER-DS011-TRJR-480019
2"
HFO
011
010102
103CL2P
10"-HFO-011010102-103CL2P-S
011-TI-0355
S
SA-JER-DS011-TRJR-480019
10"
HFO
011
010103
103CS1P
011-E-0014-C
SA-JER-DS011-TRJR-480104
S
011-E-0012-A/B
H
-
-
-
-
13.20
295.30
-
-
33.70
325.00
-
Visual Test
0.00
NFS
By Code
H
65
VACUUM RESIDUE
Liquid
947
16.07
225.00
-
-
33.10
340.00
-
H
59.73
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS
H
50
VACUUM RESIDUE
Liquid
947
16.07
225.00
-
-
33.10
340.00
-
H
59.73
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS
H
-
-
-
-
16.07
225.00
-
-
33.10
340.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS
H
65
VACUUM RESIDUE
Liquid
947
16.07
225.00
-
-
33.10
340.00
-
H
59.73
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS
155
H
50
VACUUM RESIDUE
Liquid
947
16.07
225.00
-
-
33.10
340.00
-
H
59.73
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS
155
H
65
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
if NOT insulated C or Q
SA-JER-DS011-TRJR-480019
2"
HFO
011
010103
103CS1P
10"-HFO-011010103-103CS1P-S
011-TT-0193
S
155
H
50
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480019
10"
HFO
011
010103
103CS1P
011-E-0014-F
10"-HFO-011010103-103CS1P-S
S
155
H
65
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480019
2"
HFO
011
010103
103CS1P
10"-HFO-011010103-103CS1P-S
011-TI-0053
S
155
H
50
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480019
2"
HFO
011
010103
103CS1P
10"-HFO-011010103-103CS1P-S
Blind flange
S
155
H
50
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480137
3/4"
HFO
011
010103
103CS1P
10"-HFO-011010103-103CS1P-S
011-PI-0180
S
155
H
40
VACUUM RESIDUE
Liquid
956
10.20
205.00
-
-
28.00
235.00
-
H
43.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480019
2"
HFO
011
010103
103CS1P
10"-HFO-011010103-103CS1P-S
011-TI-0054
S
155
H
50
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480019
2"
HFO
011
010103
103CS1P
10"-HFO-011010103-103CS1P-S
011-TT-0052
S
155
H
50
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
10"
HFO
011
010103
103CS1P
SA-JER-DS011-TRJR-480019
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
10"
HFO
011
010103
103CS1P
S
155
H
65
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
8"
HFO
011
010103
103CS1P
Reducer
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
10"
HFO
011
010103
103CS1P
Reducer
10"-HFO-011010103-103CS1P-S
S
155
H
65
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
6"
HFO
011
010103
103CS1P
Reducer
6"-HFO-011010103-103CS1P-S
S
155
H
65
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
8"
HFO
011
010103
103CS1P
10"-HFO-011010103-103CS1P-S
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
10"
HFO
011
010103
103CS1P
10"-HFO-011010103-103CS1P-S
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
235.00
-
H
43.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
6"
HFO
011
010103
103CS1P
6"-HFO-011010103-103CS1P-S
6"-HFO-011010103-103CS1P-S
S
155
H
65
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
235.00
-
H
43.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
Reducer
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
235.00
-
H
43.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
155
H
65
956
15.30
205.00
-
-
28.00
235.00
-
H
43.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
10"-HFO-011010103-103CS1P-S 10"-HFO-011010103-103CS1P-S
SA-JER-DS011-TRJR-480104
6"
HFO
011
010103
103CS1P
SA-JER-DS011-TRJR-480104
10"
HFO
011
010103
103CS1P
Reducer
10"-HFO-011010103-103CS1P-S
S
VACUUM RESIDUE
Liquid
SA-JER-DS011-TRJR-480104
10"
HFO
011
010103
103CS1P
10"-HFO-011010103-103CS1P-S
SA-JER-DS011-TRJR-480137
S
155
H
65
VACUUM RESIDUE
Liquid
956
10.20
205.00
-
-
28.00
235.00
-
H
43.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
6"
HFO
011
010103
103CS1P
6"-HFO-011010103-103CS1P-S
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
956
10.20
205.00
-
-
28.00
235.00
-
H
43.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-380001
Page 80 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9) HFO
011
NUMBER 010103
LINE CLASS
FROM
TO
TYPE S
TEMP. (ºC) 155
INSULATION (NOTE 2)
TYPE H
FLUID
THICKNESS (mm) 50
PHASE
(NOTE 3)
(NOTE 4) 956
OPERATING CONDITIONS PRESS. (BARG) 10.20
TEMP. (ºC) 205.00
DESIGN CONDITIONS
ALTERNATE CONDITIONS PRESS. (BARG) -
TEMP. (ºC) -
PRESS. (BARG) 28.00
STRESS TEMP
TEMP. (ºC) 235.00
(ºC) -
TEST CONDITIONS
MEDIUM (NOTE 5) H
PRESS. (BARG) 43.31
FLUID CATEGORY (ASME B.31.3)
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6) NFS
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
103CS1P
2"-FLO-011040306-101CS1P-N
10"-HFO-011010103-103CS1P-S
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
8"
HFO
011
010103
103CS1P
Reducer
10"-HFO-011010103-103CS1P-S
S
155
H
65
VACUUM RESIDUE
Liquid
956
10.20
205.00
-
-
28.00
235.00
-
H
43.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
010103
103CS1P
Plug
2"-HFO-011010103-103CS1P-S
S
155
H
40
VACUUM RESIDUE
Liquid
956
10.20
205.00
-
-
28.00
235.00
-
H
43.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480137
10"
HFO
011
010103
103CS1P
SA-JER-DS011-TRJR-480104
IP-1303-L
S
155
H
65
VACUUM RESIDUE
Liquid
956
10.20
205.00
-
-
28.00
235.00
-
H
43.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480137
2"
HFO
011
010103
103CS1P
10"-HFO-011010103-103CS1P-S
Blind flange
S
155
H
50
VACUUM RESIDUE
Liquid
956
10.20
205.00
-
-
28.00
235.00
-
H
43.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480019
6"
HFO
011
010104
103CS1P
6"-HFO-011010106-103CL2P-S
10"-HFO-011010103-103CS1P-S
S
155
H
100
VACUUM RESIDUE
Liquid
929
15.50
276.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480019
4"
HFO
011
010104
103CS1P
4"-HFO-011010106-103CL2P-S
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
929
15.50
276.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
Reducer
6"-HFO-011010104-103CS1P-S
S
155
H
100
VACUUM RESIDUE
Liquid
929
15.50
276.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
155
H
65
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
VACUUM RESIDUE
Liquid
DENSITY (kg/m3)
SA-JER-DS011-TRJR-380001
SA-JER-DS011-TRJR-480104
SA-JER-DS011-TRJR-480104
2"
UNIT
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
DOC. No.
By Code
N or Q
SA-JER-DS011-TRJR-480019
6"
HFO
011
010104
103CS1P
SA-JER-DS011-TRJR-480019
3/4"
HFO
011
010105
103CL2P
6"-HFO-011010106-103CL2P-S
Reducer
S
VACUUM RESIDUE
Liquid
SA-JER-DS011-TRJR-480019
3/4"
HFO
011
010105
103CL2P
3/4"-HFO-011010105-103CL2P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480019
2"
HFO
011
010105
103CL2P
Reducer
2"-CLD-011010302-101CH2S-P
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480019
3/4"
HFO
011
010105
103CL2P
6"-HFO-011010106-103CL2P-S
3/4"-HFO-011010105-103CL2P-S
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480019
6"
HFO
011
010106
103CL2P
10"-HFO-011014102-103CL2P-S
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480019
6"
HFO
011
010106
103CL2P
6"-HFO-011010106-103CL2P-S
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480019
4"
HFO
011
010106
103CL2P
Reducer
4"-HFO-011010104-103CS1P-S
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480019
3"
HFO
011
010106
103CL2P
Reducer
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480019
6"
HFO
011
010106
103CL2P
Reducer
6"-HFO-011010104-103CS1P-S
S
155
H
100
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480019
2"
HFO
011
010107
103CS1P
10"-HFO-011010103-103CS1P-S
2"-CLD-011010306-101CH2S-P
S
155
H
50
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480019
2"
HFO
011
010107
103CS1P
2"-HFO-011010107-103CS1P-S
Blind flange
S
155
H
50
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480019
2"
HFO
011
010108
103CS1P
10"-HFO-011010103-103CS1P-S
2"-CLD-011010308-101CH2S-P
S
155
H
50
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480019
2"
HFO
011
010108
103CS1P
2"-HFO-011010108-103CS1P-S
Blind flange
S
155
H
50
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480019
2"
HFO
011
010109
103CL2P
10"-HFO-011010102-103CL2P-S
2"-CLD-011010309-101CH2S-P
S
155
H
50
VACUUM RESIDUE
Liquid
947
16.07
225.00
-
-
33.10
340.00
-
H
59.73
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS
SA-JER-DS011-TRJR-480019
2"
HFO
011
010109
103CL2P
2"-HFO-011010109-103CL2P-S
Blind flange
S
155
H
50
VACUUM RESIDUE
Liquid
947
16.07
225.00
-
-
33.10
340.00
-
H
59.73
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS
SA-JER-DS011-TRJR-480019
2"
HFO
011
010110
103CL2P
10"-HFO-011010101-103CL2P-S
2"-CLD-011010311-101CH2S-P
S
155
H
50
VACUUM RESIDUE
Liquid
947
16.07
225.00
-
-
33.10
340.00
-
H
59.73
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS
SA-JER-DS011-TRJR-480019
2"
HFO
011
010110
103CL2P
2"-HFO-011010110-103CL2P-S
Blind flange
S
155
H
50
VACUUM RESIDUE
Liquid
947
16.07
225.00
-
-
33.10
340.00
-
H
59.73
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS
SA-JER-DS011-TRJR-480019
2"
HFO
011
010111
103CL2P
UC
Insul Brk
-
-
P
40
FRESH CRUDE
Liquid
847
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@290ºC.
SA-JER-DS011-TRJR-480019
3/4"
HFO
011
010111
103CL2P
2"-HFO-011010111-103CL2P-P
Blind flange
-
-
P
40
FRESH CRUDE
Liquid
847
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@290ºC.
SA-JER-DS011-TRJR-480019
2"
HFO
011
010111
103CL2P
Insul Brk
10"-HFO-011014102-103CL2P-S
S
155
H
65
FRESH CRUDE
Liquid
847
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480025
12"
HFO
011
013001
103CL2P
16"-HFO-011013003-103CL2P-S
SA-JER-DS011-TRJR-480024
S
31
H
100
HVGO
Liquid
818
18.99
252.00
-
170.00
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
12"
HFO
011
013001
103CL2P
SA-JER-DS011-TRJR-480025
Reducer
S
31
H
100
HVGO
Liquid
818
18.99
252.00
-
170.00
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
8"
HFO
011
013001
103CL2P
12"-HFO-011013001-103CL2P-S
Reducer
S
31
H
100
HVGO
Liquid
818
18.99
252.00
-
170.00
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
1/2"
HFO
011
013001
103CL2P
011-FE-0049
011-FT-0049
S
31
H
40
HVGO
Liquid
818
18.99
252.00
-
170.00
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
6"
HFO
011
013001
103CL2P
Reducer
6"-HFO-011013001-103CL2P-S
S
31
H
100
HVGO
Liquid
818
18.99
252.00
-
170.00
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
1/2"
HFO
011
013001
103CL2P
011-FE-0049
011-FT-0049
S
31
H
40
HVGO
Liquid
818
18.99
252.00
-
170.00
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
6"
HFO
011
013001
103CL2P
Reducer
Reducer
S
31
H
100
HVGO
Liquid
818
18.99
252.00
-
170.00
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
12"
HFO
011
013001
103CL2P
Reducer
12"-HFO-011013001-103CL2P-S
S
31
H
100
HVGO
Liquid
818
18.99
252.00
-
170.00
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
12"
HFO
011
013001
103CL2P
12"-HFO-011013001-103CL2P-S
011-E-0015-A
S
31
H
100
HVGO
Liquid
818
14.99
252.00
-
170.00
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
8"
HFO
011
013001
103CL2P
Reducer
12"-HFO-011013001-103CL2P-S
S
31
H
100
HVGO
Liquid
818
14.99
252.00
-
170.00
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
6"
HFO
011
013001
103CL2P
6"-HFO-011013001-103CL2P-S
Reducer
S
31
H
100
HVGO
Liquid
818
14.99
252.00
-
170.00
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
HFO
011
013001
103CL2P
12"-HFO-011013001-103CL2P-S
011-TT-0195
S
31
H
65
HVGO
Liquid
818
14.99
252.00
-
170.00
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
12"
HFO
011
013002
103CS1P
011-E-0015-B
SA-JER-DS011-TRJR-480016
S
31
H
100
HVGO
Liquid
831
13.95
207.00
-
-
30.00
290.00
-
H
49.90
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
HFO
011
013002
103CS1P
12"-HFO-011013002-103CS1P-S
011-TT-0068
S
31
H
50
HVGO
Liquid
831
13.95
207.00
-
-
30.00
290.00
-
H
49.90
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
12"
HFO
011
013002
103CS1P
SA-JER-DS011-TRJR-480024
12"-HFO-011013002-103CS1P-S
S
31
H
100
HVGO
Liquid
831
13.95
207.00
-
-
30.00
290.00
-
H
49.90
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
2"
HFO
011
013002
103CS1P
2"-FLO-011008304-101CS1P-N
12"-HFO-011013002-103CS1P-S
S
31
H
50
HVGO
Liquid
831
13.95
207.00
-
-
33.10
290.00
-
H
55.06
NFS
By Code
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
3/4"
HFO
011
013002
103CS1P
2"-HFO-011013002-103CS1P-S
Plug
S
31
H
40
HVGO
Liquid
831
13.95
207.00
-
-
33.10
290.00
-
H
55.06
NFS
By Code
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
2"
HFO
011
013002
103CS1P
12"-HFO-011013002-103CS1P-S
Blind flange
S
31
H
50
HVGO
Liquid
831
13.95
207.00
-
-
33.10
290.00
-
H
55.06
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480016
12"
HFO
011
013002
103CS1P
12"-HFO-011013002-103CS1P-S
011-E-0010-A
S
31
H
100
HVGO
Liquid
831
13.95
207.00
-
-
33.10
290.00
-
H
55.06
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
HFO
011
013002
103CS1P
12"-HFO-011013002-103CS1P-S
011-TT-0389
S
31
H
50
HVGO
Liquid
818
13.95
207.00
-
-
33.10
290.00
-
H
55.06
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
12"
HFO
011
013003
103CL2P
12"-HFO-011013003-103CL2P-S
Reducer
S
31
H
100
HVGO
Liquid
818
18.99
252.00
-
-
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
12"
HFO
011
013003
103CL2P
011-E-0016-B
12"-HFO-011013003-103CL2P-S
S
31
H
100
HVGO
Liquid
818
18.99
252.00
-
-
33.10
315.00
-
H
59.10
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
3/4"
HFO
011
013003
103CL2P
14"-HFO-011013003-103CL2P-S
011-PDT-0024
S
31
H
40
HVGO
Liquid
818
3.46
252.00
-
-
30.00
325.00
-
H
53.79
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
3/4"
HFO
011
013003
103CL2P
14"-HFO-011013003-103CL2P-S
011-PI-0023
S
31
H
40
HVGO
Liquid
818
3.46
252.00
-
-
30.00
325.00
-
H
53.79
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
12"
HFO
011
013003
103CL2P
12"-HFO-011013003-103CL2P-S
16"-HFO-011013003-103CL2P-S
S
31
H
100
HVGO
Liquid
818
18.99
252.00
-
-
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
16"
HFO
011
013003
103CL2P
Reducer
Reducer
S
31
H
100
HVGO
Liquid
818
18.99
252.00
-
-
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
14"
HFO
011
013003
103CL2P
SA-JER-DS011-TRJR-480025
Reducer
S
31
H
100
HVGO
Liquid
818
18.99
252.00
-
-
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
1/2"
HFO
011
013003
103CL2P
011-FE-0012
011-FT-0012
S
31
H
40
HVGO
Liquid
818
18.99
252.00
-
-
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
14"
HFO
011
013003
103CL2P
14"-HFO-011013003-103CL2P-S
Reducer
S
31
H
100
HVGO
Liquid
818
18.99
252.00
-
-
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
1/2"
HFO
011
013003
103CL2P
011-FE-0012
011-FT-0012
S
31
H
40
HVGO
Liquid
818
18.99
252.00
-
-
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
6"
HFO
011
013003
103CL2P
Reducer
6"-HFO-011013003-103CL2P-S
S
31
H
100
HVGO
Liquid
818
18.99
252.00
-
-
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
12"
HFO
011
013003
103CL2P
Reducer
Reducer
S
31
H
100
HVGO
Liquid
818
18.99
252.00
-
-
30.00
325.00
-
H
53.79
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
14"
HFO
011
013003
103CL2P
Reducer
14"-HFO-011013003-103CL2P-S
S
31
H
100
HVGO
Liquid
818
18.99
252.00
-
-
30.00
325.00
-
H
53.79
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
4"
HFO
011
013003
103CL2P
14"-HFO-011013003-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
818
18.99
252.00
-
-
30.00
325.00
-
H
53.79
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
14"
HFO
011
013003
103CL2P
14"-HFO-011013003-103CL2P-S
011-S-0001
S
31
H
100
HVGO
Liquid
818
3.46
252.00
-
-
30.00
325.00
-
H
53.79
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
14"
HFO
011
013003
103CL2P
Reducer
14"-HFO-011013003-103CL2P-S
S
31
H
100
HVGO
Liquid
818
3.46
252.00
-
-
30.00
325.00
-
H
53.79
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
2"-FLO-011013304-101CS1P-N
14"-HFO-011013003-103CL2P-S
S
31
H
65
HVGO
Liquid
818
3.46
252.00
-
-
30.00
325.00
-
H
53.79
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
31
H
40
818
3.46
252.00
-
-
30.00
325.00
-
H
53.79
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
2"
HFO
011
013003
103CL2P
SA-JER-DS011-TRJR-480141
3/4"
HFO
011
013003
103CL2P
2"-HFO-011013003-103CL2P-S
Blind flange
S
HVGO
Liquid
SA-JER-DS011-TRJR-480141
6"
HFO
011
013003
103CL2P
6"-HFO-011013003-103CL2P-S
Reducer
S
31
H
100
HVGO
Liquid
818
3.46
252.00
-
-
30.00
325.00
-
H
53.79
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
14"
HFO
011
013003
103CL2P
14"-HFO-011013003-103CL2P-S
14"-HFO-011013004-103SD0P-S
S
31
H
100
HVGO
Liquid
818
3.46
252.00
-
-
30.00
325.00
-
H
53.79
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
3/4"
HFO
011
013003
103CL2P
2"-HFO-011013003-103CL2P-S
Blind flange
S
31
H
40
HVGO
Liquid
818
3.46
252.00
-
-
30.00
325.00
-
H
53.79
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
2"
HFO
011
013003
103CL2P
2"-FLO-011013305-101CS1P-N
14"-HFO-011013003-103CL2P-S
S
31
H
65
HVGO
Liquid
818
3.46
252.00
-
-
30.00
325.00
-
H
53.79
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
3/4"
HFO
011
013003
103CL2P
14"-HFO-011013003-103CL2P-S 3/4"-HFO-011013009-103SD0P-S
S
31
H
40
HVGO
Liquid
818
3.46
252.00
-
-
30.00
325.00
-
H
53.79
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
14"
HFO
011
013003
103CL2P
SA-JER-DS011-TRJR-480141
S
31
H
100
HVGO
Liquid
818
18.99
252.00
-
-
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
12"
HFO
011
013003
103CL2P
011-E-0016-A/B
12"-HFO-011013003-103CL2P-S
S
31
H
100
HVGO
Liquid
818
18.99
252.00
-
-
33.10
-
H
59.10
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
14"
HFO
011
013004
103SD0P
14"-HFO-011013003-103CL2P-S
14"-HFO-011013006-101SD0P-S
S
31
H
100
HVGO
Liquid
818
3.46
252.00
-
-
30.00
-1.00
325.00
325.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
14"
HFO
011
013004
103SD0P
14"-HFO-011013003-103CL2P-S
Blind flange
S
31
H
100
HVGO
Liquid
818
3.46
252.00
-
-
30.00
-1.00
325.00
325.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
14"
HFO
011
013005
103SD0P
011-S-0001
14"-HFO-011013006-101SD0P-S
S
31
H
100
HVGO
Liquid
818
3.46
252.00
-
-
30.00
-1.00
325.00
325.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
3/4"
HFO
011
013005
103SD0P
14"-HFO-011013005-103SD0P-S
011-PI-0454
S
31
H
40
HVGO
Liquid
818
3.46
252.00
-
-
30.00
-1.00
325.00
325.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
14"
HFO
011
013006
101SD0P
14"-HFO-011013005-103SD0P-S
SA-JER-DS011-TRJR-480080
S
31
H
100
HVGO
Liquid
818
3.46
252.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.87
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
3/4"
HFO
011
013006
101SD0P
4"-HFO-011013006-101SD0P-S
Plug
S
31
H
40
HVGO
Liquid
818
3.46
252.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.87
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
3/4"
HFO
011
013006
101SD0P
14"-HFO-011013006-101SD0P-S
011-PI-0025
S
31
H
40
HVGO
Liquid
818
3.46
252.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.87
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
3/4"
HFO
011
013006
101SD0P
14"-HFO-011013006-101SD0P-S
011-PDT-0024
S
31
H
40
HVGO
Liquid
818
3.46
252.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.87
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
4"
HFO
011
013006
101SD0P
4"-FLO-011013308-101CS1P-N
14"-HFO-011013006-101SD0P-S
S
31
H
65
HVGO
Liquid
818
3.46
252.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.87
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
3/4"
HFO
011
013006
101SD0P
14"-HFO-011013006-101SD0P-S
011-PT-0040
S
31
H
40
HVGO
Liquid
818
3.46
252.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.87
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
14"
HFO
011
013006
101SD0P
14"-HFO-011013004-103SD0P-S 14"-HFO-011013006-101SD0P-S
S
31
H
100
HVGO
Liquid
818
3.46
252.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.87
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
14"
HFO
011
013006
101SD0P
SA-JER-DS011-TRJR-480141
011-C-0003
S
31
H
100
HVGO
Liquid
818
3.46
252.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.87
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
HFO
011
013007
103CL2P
12"-HFO-011013003-103CL2P-S
2"-CLD-011013304-101CH2S-P
S
31
H
65
HVGO
Liquid
818
18.99
252.00
-
-
33.10
315.00
-
H
59.10
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
HFO
011
013007
103CL2P
2"-HFO-011013007-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
818
18.99
252.00
-
-
33.10
315.00
-
H
59.10
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
HFO
011
013008
103CL2P
12"-HFO-011013003-103CL2P-S
2"-CLD-011013306-101CH2S-P
S
31
H
65
HVGO
Liquid
818
18.99
252.00
-
-
33.10
315.00
-
H
59.10
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
HFO
011
013008
103CL2P
2"-HFO-011013008-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
818
18.99
252.00
-
-
33.10
315.00
-
H
59.10
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
2"
HFO
011
013009
103SD0P
011-S-0001
Reducer
S
31
H
65
HVGO
Liquid
818
3.46
252.00
-
-
30.00
-1.00
325.00
325.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
4"
HFO
011
013009
103SD0P
Reducer
Reducer
S
31
H
65
HVGO
Liquid
818
3.46
252.00
-
-
30.00
-1.00
325.00
325.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Reducer
315.00
Page 81 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
INSULATION (NOTE 2)
TYPE
FLUID
THICKNESS (mm)
PHASE
(NOTE 3)
DOC. No.
DENSITY (kg/m3)
(NOTE 4)
OPERATING CONDITIONS PRESS. (BARG)
TEMP. (ºC)
DESIGN CONDITIONS
ALTERNATE CONDITIONS PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
(ºC)
TEST CONDITIONS
MEDIUM (NOTE 5)
PRESS. (BARG)
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6)
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480141
2"
HFO
011
013009
103SD0P
Reducer
2"-CLD-011013309-101CH2S-P
S
31
H
65
HVGO
Liquid
818
3.46
252.00
-
-
30.00
-1.00
325.00
325.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
3/4"
HFO
011
013009
103SD0P
2"-HFO-011013009-103SD0P-S
3/4"-OLW-011013301-101CS1PN
S
31
H
40
HVGO
Liquid
818
3.46
252.00
-
-
30.00
-1.00
325.00
325.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
3/4"
HFO
011
013009
103SD0P
14"-HFO-011013005-103SD0P-S
2"-HFO-011013009-103SD0P-S
S
31
H
40
HVGO
Liquid
818
3.46
252.00
-
-
30.00
-1.00
325.00
325.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
3/4"
HFO
011
013009
103SD0P
3/4"-HFO-011013003-103CL2P-S
2"-HFO-011013009-103SD0P-S
S
31
H
40
HVGO
Liquid
818
3.46
252.00
-
-
30.00
-1.00
325.00
325.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
2"
HFO
011
013010
103SD0P
14"-HFO-011013004-103SD0P-S
2"-CLD-011013310-101CH2S-P
S
31
H
65
HVGO
Liquid
818
3.46
252.00
-
-
30.00
-1.00
325.00
325.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
2"
HFO
011
013010
103SD0P
2"-HFO-011013010-103SD0P-S
Blind flange
S
31
H
65
HVGO
Liquid
818
3.46
252.00
-
-
30.00
-1.00
325.00
325.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
3/4"
HFO
011
013011
103CL2P
12"-HFO-011013001-103CL2P-S
Reducer
S
31
H
40
HVGO
Liquid
818
18.99
252.00
-
170.00
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
3/4"
HFO
011
013011
103CL2P
3/4"-HFO-011013011-103CL2P-S
Blind flange
S
31
H
40
HVGO
Liquid
818
18.99
252.00
-
170.00
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
HFO
011
013011
103CL2P
Reducer
2"-CLD-011013302-101CH2S-P
S
31
H
65
HVGO
Liquid
818
18.99
252.00
-
170.00
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
3/4"
HFO
011
013011
103CL2P
12"-HFO-011013001-103CL2P-S 3/4"-HFO-011013011-103CL2P-S
S
31
H
40
HVGO
Liquid
818
18.99
252.00
-
170.00
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
3/4"
HFO
011
013013
103CL2P
14"-HFO-011013003-103CL2P-S
Reducer
S
31
H
40
HVGO
Liquid
818
18.99
252.00
-
-
30.00
325.00
-
H
53.79
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
3/4"
HFO
011
013013
103CL2P
3/4"-HFO-011013013-103CL2P-S
Blind flange
S
31
H
40
HVGO
Liquid
818
18.99
252.00
-
-
30.00
325.00
-
H
53.79
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
2"
HFO
011
013013
103CL2P
Reducer
2"-CLD-011013308-101CH2S-P
S
31
H
65
HVGO
Liquid
818
18.99
252.00
-
-
30.00
325.00
-
H
53.79
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
3/4"
HFO
011
013013
103CL2P
14"-HFO-011013003-103CL2P-S 3/4"-HFO-011013013-103CL2P-S
S
31
H
40
HVGO
Liquid
818
18.99
252.00
-
-
30.00
325.00
-
H
53.79
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
3/4"
HFO
011
013014
103CL2P
10"-HFO-011039005-103CL2P-S
Reducer
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
3/4"
HFO
011
013014
103CL2P
3/4"-HFO-011013014-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
2"
HFO
011
013014
103CL2P
Reducer
2"-CLD-011013307-101CH2S-P
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480141
3/4"
HFO
011
013014
103CL2P
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480141
2"
HFO
011
013015
103SD0P
10"-HFO-011039005-103CL2P-S 3/4"-HFO-011013014-103CL2P-S 011-S-0001
2"-HFO-011013015-103SD0P-S
S
31
H
65
HVGO
Liquid
818
3.46
252.00
-
-
30.00
-1.00
325.00
325.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6 NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 425ºC NOTES 6,10 MAX. TEMPERATURE DURING FIRE SCENARIO: 425° C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 425° C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 425° C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 425ºC NOTES 6,10 MAX. TEMPERATURE DURING FIRE SCENARIO: 425° C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 425° C NOTE 10
SA-JER-DS011-TRJR-480141
2"
HFO
011
013015
103SD0P
2"-HFO-011013015-103SD0P-S
Reducer
S
31
H
65
HVGO
Liquid
818
3.46
252.00
-
-
30.00
-1.00
325.00
325.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480141
3/4"
HFO
011
013015
103SD0P
2"-HFO-011013015-103SD0P-S
Blind flange
S
31
H
40
HVGO
Liquid
818
3.46
252.00
-
-
30.00
-1.00
325.00
325.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480141
1"
HFO
011
013015
103SD0P
Reducer
011-PZV-0075
S
31
H
40
HVGO
Liquid
818
3.46
252.00
-
-
30.00
-1.00
325.00
325.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480141
2"
HFO
011
013015
103SD0P
2"-HFO-011013015-103SD0P-S
2"-HFO-011013015-103SD0P-S
S
31
H
65
HVGO
Liquid
818
3.46
252.00
-
-
30.00
-1.00
325.00
325.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480141
2"
HFO
011
013015
103SD0P
2"-HFO-011013015-103SD0P-S
2"-LFL-011013301-101CH2F-N
S
31
H
65
HVGO
Liquid
818
3.46
252.00
-
-
30.00
-1.00
325.00
325.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480141
3/4"
HFO
011
013015
103SD0P
2"-HFO-011013015-103SD0P-S
Blind flange
S
31
H
40
HVGO
Liquid
818
3.46
252.00
-
-
30.00
-1.00
325.00
325.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480024
3/4"
HFO
011
013021
103CS1P
12"-HFO-011013002-103CS1P-S
Reducer
S
31
H
40
HVGO
Liquid
831
13.95
207.00
-
-
30.00
290.00
-
H
49.90
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
3/4"
HFO
011
013021
103CS1P 3/4"-HFO-011013021-103CS1P-S
Plug
S
31
H
40
HVGO
Liquid
831
13.95
207.00
-
-
30.00
290.00
-
H
49.90
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
HFO
011
013021
103CS1P
2"-CLD-011013313-101CH2S-P
S
31
H
50
HVGO
Liquid
831
13.95
207.00
-
-
30.00
290.00
-
H
49.90
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
HFO
011
013022
103CL2P
UC
Insul Brk
-
-
P
40
HVGO
Liquid
818
18.99
252.00
-
-
33.10
315.00
-
H
59.10
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE CONDITIONS FV @ 290ºC.
SA-JER-DS011-TRJR-480025
2"
HFO
011
013022
103CL2P
2"-HFO-011013022-103CL2P-P
Blind flange
-
-
P
40
HVGO
Liquid
818
18.99
252.00
-
-
33.10
315.00
-
H
59.10
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE CONDITIONS FV @ 290ºC.
SA-JER-DS011-TRJR-480025
2"
HFO
011
013022
103CL2P
Insul Brk
12"-HFO-011013003-103CL2P-S
S
31
H
65
HVGO
Liquid
818
18.99
252.00
-
-
33.10
315.00
-
H
59.10
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE CONDITIONS FV @ 290ºC.
SA-JER-DS011-TRJR-480025
2"
HFO
011
013023
103CL2P
UC
Insul Brk
-
-
P
40
HVGO
Liquid
818
18.99
252.00
-
-
33.10
315.00
-
H
59.10
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE CONDITIONS FV @ 290ºC.
SA-JER-DS011-TRJR-480025
2"
HFO
011
013023
103CL2P
2"-HFO-011013023-103CL2P-P
Blind flange
-
-
P
40
HVGO
Liquid
818
18.99
252.00
-
-
33.10
315.00
-
H
59.10
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE CONDITIONS FV @ 290ºC.
SA-JER-DS011-TRJR-480025
2"
HFO
011
013023
103CL2P
Insul Brk
12"-HFO-011013003-103CL2P-S
S
31
H
65
HVGO
Liquid
818
18.99
252.00
-
-
33.10
315.00
-
H
59.10
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE CONDITIONS FV @ 290ºC.
SA-JER-DS011-TRJR-480025
2"
HFO
011
013025
103CL2P
12"-HFO-011015003-103CL2P-S
2"-CLD-011013317-101CH2S-P
S
31
H
65
HVGO
Liquid
818
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
HFO
011
013025
103CL2P
2"-HFO-011013025-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
818
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
HFO
011
013026
103CL2P
12"-HFO-011015003-103CL2P-S
2"-CLD-011013318-101CH2S-P
S
31
H
65
HVGO
Liquid
818
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
HFO
011
013026
103CL2P
2"-HFO-011013026-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
818
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
HFO
011
013027
103CL2P
12"-HFO-011013001-103CL2P-S
2"-CLD-011013320-101CH2S-P
S
31
H
65
HVGO
Liquid
818
14.99
252.00
-
170.00
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
HFO
011
013027
103CL2P
2"-HFO-011013027-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
818
14.99
252.00
-
170.00
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
2"
HFO
011
013028
103CL2P
12"-HFO-011013001-103CL2P-S
2"-CLD-011013320-101CH2S-P
S
31
H
65
HVGO
Liquid
818
14.99
252.00
-
170.00
30.00
315.00
-
H
53.56
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
2"
HFO
011
013324
103SD0P
UC
011-S-0001
S
31
H
65
HVGO
Liquid
818
3.46
252.00
-
-
30.00
-1.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS : 0.5 bara @ 150° C
SA-JER-DS011-TRJR-480141
Liquid
-1.00
Reducer
325.00
325.00
325.00
325.00
3/4"
HFO
011
013324
103SD0P
2"-HFO-011013324-103SD0P-P
Blind flange
S
31
H
40
HVGO
818
3.46
252.00
-
-
30.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS : 0.5 bara @ 150° C
SA-JER-DS011-TRJR-480141
-
HFO
011
013601
103SD0P
011-S-0001
TRIM
S
31
H
-
-
-
-
5.10
268.00
-
-
30.00
325.00
-
Visual Test
0.00
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 bara @ 150ºC.
SA-JER-DS011-TRJR-480141
2"
HFO
011
013601
103SD0P
011-S-0001
011-S-0001
S
31
H
65
-
Liquid
818
5.10
268.00
-
-
30.00
325.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 bara @ 150ºC.
SA-JER-DS011-TRJR-480141
2"
HFO
011
013601
103SD0P
011-S-0001
Blind flange
S
31
H
65
-
Liquid
818
5.10
268.00
-
-
30.00
325.00
-
H
53.26
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 bara @ 150ºC.
N
POTENTIAL
N
N
N
N
-
NOTE 6
if insulated N or Q SA-JER-DS011-TRJR-480024
-
HFO
011
013602
106CS1P
011-E-0015-A/B
TRIM
-
-
H
-
-
-
-
17.00
258.00
-
-
33.10
290.00
-
Visual Test
0.00
NFS
By Code
SA-JER-DS011-TRJR-480026
10"
HFO
011
014001
103CL2P
14"-HFO-011022002-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
10"
HFO
011
014001
103CL2P
10"-HFO-011014001-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
8"
HFO
011
014001
103CL2P
Reducer
8"-HFO-011014001-103CL2P-H
-
-
H
100
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
Reducer
Reducer
-
-
H
100
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
100
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
if NOT insulated C or Q
SA-JER-DS011-TRJR-480026
8"
HFO
011
014001
103CL2P
SA-JER-DS011-TRJR-480026
10"
HFO
011
014001
103CL2P
Reducer
10"-HFO-011014001-103CL2P-H
-
HAGO
Liquid
SA-JER-DS011-TRJR-480026
10"
HFO
011
014001
103CL2P
10"-HFO-011014001-103CL2P-H
14"-HFO-011014002-103CL2P-H
-
-
H
100
HAGO
Liquid
695
8.73
275.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
10"
HFO
011
014001
103CL2P
Reducer
10"-HFO-011014001-103CL2P-H
-
-
H
100
HAGO
Liquid
695
8.73
275.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
8"
HFO
011
014001
103CL2P
8"-HFO-011014001-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
695
8.73
275.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
12"
HFO
011
014002
103CL2P
011-E-0017-A/B
Reducer
-
-
H
100
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
12"
HFO
011
014002
103CL2P
011-E-0017-A
Reducer
-
-
H
100
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
10"
HFO
011
014002
103CL2P
Reducer
Reducer
-
-
H
100
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
014002
103CL2P
10"-HFO-011014002-103CL2P-H
011-TI-0075
-
-
H
65
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
10"
HFO
011
014002
103CL2P
Reducer
Reducer
-
-
H
100
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
014002
103CL2P
10"-HFO-011014002-103CL2P-H
011-TI-0071
-
-
H
65
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
14"
HFO
011
014002
103CL2P
Reducer
Reducer
-
-
H
100
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
1/2"
HFO
011
014002
103CL2P
011-FE-0013
011-FT-0013
-
-
H
40
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
1/2"
HFO
011
014002
103CL2P
011-FE-0013
011-FT-0013
-
-
H
40
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
3/4"
HFO
011
014002
103CL2P
14"-HFO-011014002-103CL2P-H
011-PDT-0146
-
-
H
65
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
10"
HFO
011
014002
103CL2P
Reducer
10"-HFO-011014007-101CL2P-H
-
-
H
100
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
14"
HFO
011
014002
103CL2P
14"-HFO-011014002-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
014002
103CL2P
14"-HFO-011014002-103CL2P-H
011-TT-0079
-
-
H
65
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
12"
HFO
011
014002
103CL2P
Reducer
Reducer
-
-
H
100
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
14"
HFO
011
014002
103CL2P
Reducer
14"-HFO-011014007-101CL2P-H
-
-
H
100
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
014003
103CL2P
10"-HFO-011014002-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
014003
103CL2P
Insul Brk
2"-CLD-011014303-101CH2S-P
-
-
P
40
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
014003
103CL2P
2"-HFO-011014003-103CL2P-P
Blind flange
-
-
P
40
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
014004
103CL2P
10"-HFO-011014002-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
014004
103CL2P
Insul Brk
2"-CLD-011014304-101CH2S-P
-
-
P
40
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
014004
103CL2P
2"-HFO-011014004-103CL2P-P
Blind flange
-
-
P
40
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
3/4"
HFO
011
014005
103CL2P
Insul Brk
Reducer
-
-
P
40
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
3/4"
HFO
011
014005
103CL2P
3/4"-HFO-011014005-103CL2P-P
Blind flange
-
-
P
40
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
014005
103CL2P
Reducer
2"-CLD-011014305-101CH2S-P
-
-
P
40
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
3/4"
HFO
011
014005
103CL2P
10"-HFO-011014001-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
3/4"
HFO
011
014005
103CL2P
Insul Brk
3/4"-HFO-011014005-103CL2P-P
-
-
P
40
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
3/4"
HFO
011
014005
103CL2P
10"-HFO-011014001-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
3/4"
HFO
011
014006
103CL2P
14"-HFO-011014002-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
3/4"
HFO
011
014006
103CL2P
Insul Brk
Reducer
-
-
P
40
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
3/4"
HFO
011
014006
103CL2P
3/4"-HFO-011014006-103CL2P-P
Blind flange
-
-
P
40
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
014006
103CL2P
Reducer
2"-CLD-011014306-101CH2S-P
-
-
P
40
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 82 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9) HFO
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
011
014007
101CL2P
-
FLUID
PHASE
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
14"-HFO-011014002-103CL2P-H
SA-JER-DS011-TRJR-480044
-
H
100
HAGO
Liquid
707
4.14
262.00
-
170.00
5.40
390.00
-
H
11.41
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
4"
HFO
011
014007
101CL2P
14"-HFO-011014007-101CL2P-H
Blind flange
-
-
H
65
HAGO
Liquid
707
4.14
262.00
-
170.00
5.40
390.00
-
H
11.41
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
10"
HFO
011
014007
101CL2P
10"-HFO-011014002-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
707
4.14
262.00
-
170.00
5.40
390.00
-
H
11.41
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
14"
HFO
011
014007
101CL2P
Reducer
14"-HFO-011014007-101CL2P-H
-
-
H
100
HAGO
Liquid
707
4.14
262.00
-
170.00
5.40
390.00
-
H
11.41
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
14"
HFO
011
014007
101CL2P
SA-JER-DS011-TRJR-480026
Reducer
-
-
H
100
HAGO
Liquid
707
4.14
262.00
-
170.00
5.40
390.00
-
H
11.41
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
14"
HFO
011
014007
101CL2P
14"-HFO-011014007-101CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
707
4.14
262.00
-
170.00
5.40
390.00
-
H
11.41
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
10"
HFO
011
014007
101CL2P
Reducer
011-C-0002
-
-
H
100
HAGO
Liquid
707
4.14
262.00
-
-
5.40
390.00
-
H
11.41
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
10"
HFO
011
014007
101CL2P
Reducer
011-C-0002
-
-
H
100
HAGO
Liquid
707
4.14
262.00
-
-
5.40
390.00
-
H
11.41
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
014008
103CL2P
UC
Insul Brk
-
-
P
40
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290ºC
SA-JER-DS011-TRJR-480026
3/4"
HFO
011
014008
103CL2P
2"-HFO-011014008-103CL2P-P
Blind flange
-
-
P
40
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290ºC
SA-JER-DS011-TRJR-480026
2"
HFO
011
014008
103CL2P
Insul Brk
10"-HFO-011014002-103CL2P-H
-
-
H
65
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290ºC
SA-JER-DS011-TRJR-480026
2"
HFO
011
014009
103CL2P
UC
Insul Brk
-
-
P
40
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290ºC
SA-JER-DS011-TRJR-480026
3/4"
HFO
011
014009
103CL2P
2"-HFO-011014009-103CL2P-P
Blind flange
-
-
P
40
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290ºC
SA-JER-DS011-TRJR-480026
2"
HFO
011
014009
103CL2P
Insul Brk
10"-HFO-011014002-103CL2P-H
-
-
H
65
HAGO
Liquid
707
8.73
262.00
-
170.00
18.50
310.00
-
H
32.98
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290ºC
SA-JER-DS011-TRJR-480026
3/4"
HFO
011
014010
103CL2P
14"-HFO-011022002-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
3/4"
HFO
011
014010
103CL2P
Insul Brk
Reducer
-
-
P
40
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
3/4"
HFO
011
014010
103CL2P
3/4"-HFO-011014010-103CL2P-P
Blind flange
-
-
P
40
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
014010
103CL2P
Reducer
2"-CLD-011014313-101CH2S-P
-
-
P
40
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
014011
103CL2P
10"-HFO-011022002-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
697
8.80
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
014011
103CL2P
Insul Brk
2"-CLD-011014314-101CH2S-P
-
-
P
40
HAGO
Liquid
697
8.80
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
014011
103CL2P
2"-HFO-011014011-103CL2P-P
Blind flange
-
-
P
40
HAGO
Liquid
697
8.80
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
014012
103CL2P
10"-HFO-011022002-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
697
8.80
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
014012
103CL2P
Insul Brk
2"-CLD-011014315-101CH2S-P
-
-
P
40
HAGO
Liquid
697
8.80
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480026
2"
HFO
011
014012
103CL2P
2"-HFO-011014012-103CL2P-P
Blind flange
-
-
P
40
HAGO
Liquid
697
8.80
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480027
8"
HFO
011
014101
103CL4P
12"-HFO-011015103-103CL4P-S
8"-HFO-011014105-103CL2P-S
S
155
H
100
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
8"
HFO
011
014101
103CL4P
8"-HFO-011014101-103CL4P-S
8"-HFO-011014105-103CL2P-S
S
155
H
100
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
-
HFO
011
014101
103CL4P
011-E-0018-A/B/C/D/E/F
TRIM
-
-
H
100
VACUUM RESIDUE
Liquid
908.9
16.50
308.00
-
-
28.00
390.00
-
Visual Test
0.00
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
10"
HFO
011
014102
103CL2P
011-E-0018-B/D
10"-HFO-011014102-103CL2P-S
S
155
H
100
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
33.10
340.00
-
H
59.73
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
2"
HFO
011
014102
103CL2P
10"-HFO-011014102-103CL2P-S
Flange
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
33.10
340.00
-
H
59.73
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
10"
HFO
011
014102
103CL2P
10"-HFO-011014102-103CL2P-S
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
12"
HFO
011
014102
103CL2P
Reducer
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480019
10"
HFO
011
014102
103CL2P
SA-JER-DS011-TRJR-480027
011-E-0014-A
S
155
H
100
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480019
10"
HFO
011
014102
103CL2P
10"-HFO-011014102-103CL2P-S
011-E-0014-D
S
155
H
100
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
10"
HFO
011
014102
103CL2P
Reducer
SA-JER-DS011-TRJR-480019
S
155
H
100
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
10"
HFO
011
014102
103CL2P
011-E-0018-D
10"-HFO-011014102-103CL2P-S
S
155
H
100
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
33.10
340.00
-
H
59.73
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
10"
HFO
011
014102
103CL2P
10"-HFO-011014102-103CL2P-S
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
12"
HFO
011
014102
103CL2P
Reducer
12"-HFO-011014102-103CL2P-S
S
155
H
100
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
6"
HFO
011
014103
103CL2P
10"-HFO-011014102-103CL2P-S
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
6"
HFO
011
014103
103CL2P
6"-HFO-011014103-103CL2P-S
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
1/2"
HFO
011
014103
103CL2P
011-FE-0063
011-FT-0063-A
S
155
H
40
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
2"
HFO
011
014103
103CL2P
2"-FLO-011014305-101CS1P-N
6"-HFO-011014103-103CL2P-S
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
1/2"
HFO
011
014103
103CL2P
011-FE-0063
011-FT-0063-B
S
155
H
40
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
1/2"
HFO
011
014103
103CL2P
011-FE-0063
011-FT-0063-A
S
155
H
40
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480026
14"
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
DOC. No.
NOTE 6
SA-JER-DS011-TRJR-480027
3"
HFO
011
014103
103CL2P
Reducer
3"-HFO-011014104-101CL2P-S
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
3/4"
HFO
011
014103
103CL2P
2"-HFO-011014103-103CL2P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
1/2"
HFO
011
014103
103CL2P
011-FE-0063
011-FT-0063-B
S
155
H
40
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
4"
HFO
011
014103
103CL2P
Reducer
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
6"
HFO
011
014103
103CL2P
Reducer
6"-HFO-011014104-101CL2P-S
S
155
H
100
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
6"
HFO
011
014104
101CL2P
6"-HFO-011014103-103CL2P-S
SA-JER-DS011-TRJR-480081
S
155
H
100
VACUUM RESIDUE
Liquid
929
0.67
276.00
-
-
4.70
-1.00
340.00
340.00
-
H
8.48
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
3"
HFO
011
014104
101CL2P
3"-HFO-011014103-103CL2P-S
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
929
0.67
276.00
-
-
4.70
-1.00
340.00
340.00
-
H
8.48
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
6"
HFO
011
014104
101CL2P
Reducer
6"-HFO-011014104-101CL2P-S
S
155
H
100
VACUUM RESIDUE
Liquid
929
0.67
276.00
-
-
4.70
-1.00
340.00
340.00
-
H
8.48
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
6"
HFO
011
014104
101CL2P
SA-JER-DS011-TRJR-480027
011-C-0003
S
155
H
100
VACUUM RESIDUE
Liquid
929
0.67
276.00
-
-
4.70
-1.00
340.00
340.00
-
H
8.48
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
3/4"
HFO
011
014104
101CL2P
4"-HFO-011014104-101CL2P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
929
0.67
276.00
-
-
4.70
-1.00
340.00
340.00
-
H
8.48
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
4"
HFO
011
014104
101CL2P
4"-FLO-011030302-101CS1P-N
6"-HFO-011014104-101CL2P-S
S
155
H
65
VACUUM RESIDUE
Liquid
929
0.67
276.00
-
-
4.70
-1.00
340.00
340.00
-
H
8.48
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
8"
HFO
011
014105
103CL2P
8"-HFO-011014101-103CL4P-S
12"-HFO-011014102-103CL2P-S
S
155
H
100
VACUUM RESIDUE
Liquid
908.9
16.70
308.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
8"
HFO
011
014105
103CL2P
8"-HFO-011014101-103CL4P-S
8"-HFO-011014105-103CL2P-S
S
155
H
100
VACUUM RESIDUE
Liquid
908.9
16.70
308.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
1"
HFO
011
014106
103CL4P
8"-HFO-011014101-103CL4P-S
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
1"
HFO
011
014106
103CL4P
1"-HFO-011014106-103CL4P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
2"
HFO
011
014106
103CL4P
Reducer
2"-CLD-011014311-101CH2S-P
S
155
H
65
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
1"
HFO
011
014106
103CL4P
8"-HFO-011014101-103CL4P-S
1"-HFO-011014106-103CL4P-S
S
155
H
65
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
3/4"
HFO
011
014107
103CL2P
6"-HFO-011014103-103CL2P-S
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
3/4"
HFO
011
014107
103CL2P
3/4"-HFO-011014107-103CL2P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
2"
HFO
011
014107
103CL2P
Reducer
2"-CLD-011014312-101CH2S-P
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
3/4"
HFO
011
014107
103CL2P
6"-HFO-011014103-103CL2P-S
3/4"-HFO-011014107-103CL2P-S
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
2"
HFO
011
014108
103CL2P
10"-HFO-011014102-103CL2P-S
2"-CLD-011014310-101CH2S-P
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
33.10
340.00
-
H
59.73
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
2"
HFO
011
014108
103CL2P
2"-HFO-011014108-103CL2P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
33.10
340.00
-
H
59.73
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
2"
HFO
011
014109
103CL2P
10"-HFO-011014102-103CL2P-S
2"-CLD-011014308-101CH2S-P
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
33.10
340.00
-
H
59.73
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
2"
HFO
011
014109
103CL2P
2"-HFO-011014109-103CL2P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
33.10
340.00
-
H
59.73
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
2"
HFO
011
014110
103CL2P
UC
Insul Brk
-
-
P
40
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
33.10
340.00
-
H
59.73
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC.
SA-JER-DS011-TRJR-480027
3/4"
HFO
011
014110
103CL2P
2"-HFO-011014110-103CL2P-P
Blind flange
-
-
P
40
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
33.10
340.00
-
H
59.73
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC.
SA-JER-DS011-TRJR-480027
2"
HFO
011
014110
103CL2P
Insul Brk
10"-HFO-011014102-103CL2P-S
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
33.10
340.00
-
H
59.73
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
2"
HFO
011
014111
103CL2P
UC
Insul Brk
-
-
P
40
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
33.10
340.00
-
H
59.73
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC.
SA-JER-DS011-TRJR-480027
3/4"
HFO
011
014111
103CL2P
2"-HFO-011014111-103CL2P-P
Blind flange
P
40
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
33.10
340.00
-
H
59.73
NFS
YES
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC.
SA-JER-DS011-TRJR-480027
2"
HFO
011
014111
103CL2P
Insul Brk
10"-HFO-011014102-103CL2P-S
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
33.10
340.00
-
H
59.73
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
2"
HFO
011
014112
103CL4P
2"-HFO-011014112-103CL4P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
929
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
2"
HFO
011
014112
103CL4P
10"-HFO-011015103-103CL4P-S
2"-CLD-011014317-101CH2S-P
S
155
H
65
VACUUM RESIDUE
Liquid
929
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
2"
HFO
011
014113
103CL4P
10"-HFO-011015103-103CL4P-S
2"-CLD-011014319-101CH2S-P
S
155
H
65
VACUUM RESIDUE
Liquid
929
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
2"
HFO
011
014113
103CL4P
2"-HFO-011014113-103CL4P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
929
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
3/4"
HFO
011
014114
103CL2P
6"-HFO-011014103-103CL2P-S
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
3/4"
HFO
011
014114
103CL2P
3/4"-HFO-011014114-103CL2P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
2"
HFO
011
014114
103CL2P
Reducer
2"-CLD-011014320-101CH2S-P
S
155
H
65
VACUUM RESIDUE
Liquid
929
16.70
276.00
-
-
28.00
340.00
-
H
50.53
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480028
12"
HFO
011
015001
103CL2P
011-E-0019-B
011-E-0019-C
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
015001
103CL2P
12"-HFO-011015001-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
12"
HFO
011
015002
103CL2P
011-E-0019-E
011-E-0019-F
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
015002
103CL2P
12"-HFO-011015002-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
12"
HFO
011
015003
103CL2P
011-E-0019-C/F
12"-HFO-011015003-103CL2P-S
S
31
H
100
HVGO
Liquid
802
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
12"
HFO
011
015003
103CL2P
011-E-0019-F
12"-HFO-011015003-103CL2P-S
S
31
H
100
HVGO
Liquid
802
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
12"
HFO
011
015003
103CL2P
12"-HFO-011015003-103CL2P-S
Reducer
S
31
H
100
HVGO
Liquid
802
19.58
280.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
12"
HFO
011
015003
103CL2P
12"-HFO-011015003-103CL2P-S
Reducer
S
31
H
100
HVGO
Liquid
802
19.58
280.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
18"
HFO
011
015003
103CL2P
Reducer
SA-JER-DS011-TRJR-480025
S
31
H
100
HVGO
Liquid
802
19.58
280.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
18"
HFO
011
015003
103CL2P
Reducer
18"-HFO-011015003-103CL2P-S
S
31
H
100
HVGO
Liquid
802
19.58
280.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
-
-
Q
Page 83 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480025
18"
HFO
011
015003
103CL2P
SA-JER-DS011-TRJR-480028
Reducer
S
31
H
100
HVGO
Liquid
802
19.58
280.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
18"
HFO
011
015003
103CL2P
18"-HFO-011015003-103CL2P-S
Reducer
S
31
H
100
HVGO
Liquid
802
19.58
280.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
12"
HFO
011
015003
103CL2P
Reducer
12"-HFO-011015003-103CL2P-S
S
31
H
100
HVGO
Liquid
802
19.58
280.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
HFO
011
015003
103CL2P
2"-FLO-011013302-101CS1P-N
12"-HFO-011015003-103CL2P-S
S
31
H
65
HVGO
Liquid
802
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
12"
HFO
011
015003
103CL2P
12"-HFO-011015003-103CL2P-S
011-E-0016-B
S
31
H
100
HVGO
Liquid
802
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
12"
HFO
011
015003
103CL2P
Reducer
12"-HFO-011015003-103CL2P-S
S
31
H
100
HVGO
Liquid
802
19.58
280.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
HFO
011
015003
103CL2P
2"-FLO-011013303-101CS1P-N
12"-HFO-011015003-103CL2P-S
S
31
H
65
HVGO
Liquid
802
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
12"-HFO-011015003-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
802
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
31
H
65
802
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
HFO
011
015003
103CL2P
SA-JER-DS011-TRJR-480025
3/4"
HFO
011
015003
103CL2P
2"-HFO-011015003-103CL2P-S
Blind flange
S
HVGO
Liquid
SA-JER-DS011-TRJR-480025
3/4"
HFO
011
015003
103CL2P
2"-HFO-011015003-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
802
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
12"
HFO
011
015003
103CL2P
12"-HFO-011015003-103CL2P-S
011-E-0016-A/B
S
31
H
100
HVGO
Liquid
802
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480025
2"
HFO
011
015003
103CL2P
12"-HFO-011015003-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
802
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
10"
HFO
011
015004
103CL2P
18"-HFO-011039003-103CL2P-S
18"-HFO-011015003-103CL2P-S
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
015005
103CL2P
12"-HFO-011015003-103CL2P-S
2"-CLD-011015302-101CH2S-P
S
31
H
65
HVGO
Liquid
802
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
015005
103CL2P
2"-HFO-011015005-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
802
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
015006
103CL2P
12"-HFO-011015001-103CL2P-S
2"-CLD-011015306-101CH2S-P
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
015006
103CL2P
2"-HFO-011015006-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
015007
103CL2P
12"-HFO-011015002-103CL2P-S
2"-CLD-011015308-101CH2S-P
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
015007
103CL2P
2"-HFO-011015007-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
015008
103CL2P
12"-HFO-011015003-103CL2P-S
2"-CLD-011015304-101CH2S-P
S
31
H
65
HVGO
Liquid
802
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
015008
103CL2P
2"-HFO-011015008-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
802
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
015009
103CL2P
UC
Insul Brk
-
-
P
40
HVGO
Liquid
802
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480028
3/4"
HFO
011
015009
103CL2P
2"-HFO-011015009-103CL2P-P
Blind flange
-
-
P
Liquid
802
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480028
2"
HFO
011
015009
103CL2P
Insul Brk
12"-HFO-011015003-103CL2P-S
S
31
H
65
HVGO
Liquid
802
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480028
2"
HFO
011
015010
103CL2P
UC
Insul Brk
-
31
P
40
HVGO
Liquid
802
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480028
3/4"
HFO
011
015010
103CL2P
2"-HFO-011015010-103CL2P-P
Blind flange
-
31
P
40
HVGO
Liquid
802
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480028
2"
HFO
011
015010
103CL2P
Insul Brk
12"-HFO-011015003-103CL2P-S
S
31
H
65
HVGO
Liquid
802
19.58
280.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480028
2"
HFO
011
015011
103CL2P
12"-HFO-011039003-103CL2P-S
2"-CLD-011015319-101CH2S-P
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
015011
103CL2P
2"-HFO-011015011-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
015012
103CL2P
12"-HFO-011039003-103CL2P-S
2"-CLD-011015321-101CH2S-P
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
015012
103CL2P
2"-HFO-011015012-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
015013
103CL2P
10"-HFO-011015004-103CL2P-S
2"-CLD-011015322-101CH2S-P
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
015013
103CL2P
2"-HFO-011015013-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480029
10"
HFO
011
015101
103CL4P
011-E-0020-B
011-E-0020-C
S
155
H
100
VACUUM RESIDUE
Liquid
902.3
17.50
321.80
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015101
103CL4P
10"-HFO-011015101-103CL4P-S
UC
S
155
H
65
VACUUM RESIDUE
Liquid
902.3
17.50
321.80
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
-
HFO
011
015101
103CL4P
011-E-0020-A/B/C/D/E/F
TRIM
-
-
H
100
VACUUM RESIDUE
Liquid
902.3
17.50
360.00
-
-
33.10
390.00
-
Visual Test
0.00
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
40
HVGO
SA-JER-DS011-TRJR-480029
2"
HFO
011
015101
103CL4P
10"-HFO-011015101-103CL4P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
902.3
17.50
321.80
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
10"
HFO
011
015102
103CL4P
011-E-0020-E
011-E-0020-F
S
155
H
100
VACUUM RESIDUE
Liquid
902.3
17.50
321.84
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015102
103CL4P
10"-HFO-011015102-103CL4P-S
UC
S
155
H
65
VACUUM RESIDUE
Liquid
902.3
17.50
321.84
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015102
103CL4P
10"-HFO-011015102-103CL4P-S
011-TW-0319
S
155
H
65
VACUUM RESIDUE
Liquid
902.3
17.50
321.84
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
10"
HFO
011
015103
103CL4P
10"-HFO-011015103-103CL4P-S
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
10"
HFO
011
015103
103CL4P
10"-HFO-011015103-103CL4P-S
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
12"
HFO
011
015103
103CL4P
Reducer
SA-JER-DS011-TRJR-480027
S
155
H
100
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
12"
HFO
011
015103
103CL4P
Reducer
12"-HFO-011015103-103CL4P-S
S
155
H
100
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
12"
HFO
011
015103
103CL4P
SA-JER-DS011-TRJR-480029
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
12"
HFO
011
015103
103CL4P
12"-HFO-011015103-103CL4P-S
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
10"
HFO
011
015103
103CL4P
Reducer
10"-HFO-011015103-103CL4P-S
S
155
H
100
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
10"
HFO
011
015103
103CL4P
Reducer
10"-HFO-011015103-103CL4P-S
S
155
H
100
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
10"
HFO
011
015103
103CL4P
10"-HFO-011015103-103CL4P-S
011-E-0018-A/C
S
155
H
100
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
2"
HFO
011
015103
103CL4P
10"-HFO-011015103-103CL4P-S
UC
S
155
H
65
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
Not attached
UC
S
155
H
65
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
155
H
100
908.9
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
2"
HFO
011
015103
103CL4P
SA-JER-DS011-TRJR-480027
10"
HFO
011
015103
103CL4P
10"-HFO-011015103-103CL4P-S
011-E-0018-C
S
VACUUM RESIDUE
Liquid
SA-JER-DS011-TRJR-480027
2"
HFO
011
015103
103CL4P
2"-FLO-011014302-101CS1P-N
10"-HFO-011015103-103CL4P-S
S
155
H
65
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
1"
HFO
011
015103
103CL4P
2"-HFO-011015103-103CL4P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
1"
HFO
011
015103
103CL4P
2"-HFO-011015103-103CL4P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480027
2"
HFO
011
015103
103CL4P
2"-FLO-011014304-101CS1P-N
10"-HFO-011015103-103CL4P-S
S
155
H
65
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
10"
HFO
011
015103
103CL4P
011-E-0020-C/F
10"-HFO-011015103-103CL4P-S
S
155
H
100
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
10"
HFO
011
015103
103CL4P
011-E-0020-F
10"-HFO-011015103-103CL4P-S
S
155
H
100
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015103
103CL4P
10"-HFO-011015103-103CL4P-S
011-TI-0315
S
155
H
65
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
10"
HFO
011
015104
103CL4P
12"-HFO-011039103-103CL4P-S
12"-HFO-011015103-103CL4P-S
S
155
H
100
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015105
103CL4P
10"-HFO-011015103-103CL4P-S
2"-CLD-011015310-101CH2S-P
S
155
H
65
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015105
103CL4P
2"-HFO-011015105-103CL4P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015106
103CL4P
10"-HFO-011015102-103CL4P-S
2"-CLD-011015316-101CH2S-P
S
155
H
65
VACUUM RESIDUE
Liquid
902.3
17.50
321.84
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015106
103CL4P
2"-HFO-011015106-103CL4P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
902.3
17.50
321.84
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015107
103CL4P
10"-HFO-011015103-103CL4P-S
2"-CLD-011015312-101CH2S-P
S
155
H
65
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015107
103CL4P
2"-HFO-011015107-103CL4P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015108
103CL4P
10"-HFO-011015101-103CL4P-S
2"-CLD-011015314-101CH2S-P
S
155
H
65
VACUUM RESIDUE
Liquid
902.3
17.50
321.80
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015108
103CL4P
2"-HFO-011015108-103CL4P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
902.3
17.50
321.80
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015109
103CL4P
UC
Insul Brk
-
-
P
50
VACUUM RESIDUE
Liquid
929
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC.
SA-JER-DS011-TRJR-480029
1"
HFO
011
015109
103CL4P
2"-HFO-011015109-103CL4P-P
Blind flange
-
-
P
40
VACUUM RESIDUE
Liquid
929
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015109
103CL4P
Insul Brk
10"-HFO-011015103-103CL4P-S
S
155
H
65
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015110
103CL4P
UC
Insul Brk
-
-
P
50
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC.
SA-JER-DS011-TRJR-480029
1"
HFO
011
015110
103CL4P
2"-HFO-011015110-103CL4P-P
Blind flange
-
-
P
40
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015110
103CL4P
Insul Brk
10"-HFO-011015103-103CL4P-S
S
155
H
65
VACUUM RESIDUE
Liquid
908.9
17.50
308.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015111
103CL4P
10"-HFO-011039103-103CL4P-S
2"-CLD-011015325-101CH2S-P
S
155
H
75
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015111
103CL4P
2"-HFO-011015111-103CL4P-S
Blind flange
S
155
H
75
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015112
103CL4P
10"-HFO-011039103-103CL4P-S
2"-CLD-011015328-101CH2S-P
S
155
H
75
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015112
103CL4P
2"-HFO-011015112-103CL4P-S
Blind flange
S
155
H
75
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015113
103CL4P
10"-HFO-011015104-103CL4P-S
2"-CLD-011015326-101CH2S-P
S
155
H
75
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
015113
103CL4P
2"-HFO-011015113-103CL4P-S
Blind flange
S
155
H
75
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
N
POTENTIAL
N
N
N
N
-
NOTE 6
Q
if insulated N or Q SA-JER-DS011-TRJR-480028
-
HFO
011
015601
103CL2P
011-E-0019-A/B/C/D/E/F
TRIM
-
-
H
-
-
-
-
19.40
323.00
-
-
33.00
355.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480044
28"
HFO
011
018001
SA-JER-DS011-TRJR-480044
2"
HFO
011
018001
101CL2P
011-C-0002
SA-JER-DS011-TRJR-480056
-
-
H
100
HAGO
Liquid
665
3.30
309.00
-
-
5.74
390.00
-
H
12.13
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
101CL2P
28"-HFO-011018001-101CL2P-H
011-TT-0109
-
-
H
65
HAGO
Liquid
665
3.30
309.00
-
-
5.74
390.00
-
H
12.13
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
SA-JER-DS011-TRJR-480044
28"
HFO
011
-
NOTE 6
018001
101CL2P
011-C-0002
28"-HFO-011018001-101CL2P-H
-
-
H
100
HAGO
Liquid
665
3.30
309.00
-
-
5.74
390.00
-
H
12.13
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480056
28"
HFO
NOTE 6
011
018001
101CL2P
SA-JER-DS011-TRJR-480044
Reducer
-
-
H
100
HAGO
Liquid
665
3.30
309.00
-
-
5.74
390.00
-
H
12.13
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480056
26"
NOTE 6
HFO
011
018001
101CL2P
Reducer
SA-JER-DS011-TRJR-480065
-
-
H
100
HAGO
Liquid
665
3.30
309.00
-
-
5.74
390.00
-
H
12.13
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480065
NOTE 6
26"
HFO
011
018001
101CL2P
SA-JER-DS011-TRJR-480056
Reducer
-
-
H
100
HAGO
Liquid
665
3.30
309.00
-
-
5.74
390.00
-
H
12.13
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480065
NOTE 6
20"
HFO
011
018001
101CL2P
Reducer
20"-HFO-011027001-103CL2P-H
-
-
H
100
HAGO
Liquid
665
3.30
309.00
-
-
5.74
390.00
-
H
12.13
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
if NOT insulated C or Q
Page 84 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
INSULATION (NOTE 2)
TYPE
FLUID
THICKNESS (mm)
PHASE
(NOTE 3)
DOC. No.
DENSITY (kg/m3)
(NOTE 4)
OPERATING CONDITIONS PRESS. (BARG)
TEMP. (ºC)
DESIGN CONDITIONS
ALTERNATE CONDITIONS PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
(ºC)
TEST CONDITIONS
MEDIUM (NOTE 5)
PRESS. (BARG)
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6)
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480065
26"
HFO
011
018001
101CL2P
26"-HFO-011018001-101CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
665
3.30
309.00
-
-
5.74
390.00
-
H
12.13
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
20"
HFO
011
018001
101CL2P
Reducer
20"-HFO-011027002-103CL2P-H
-
-
H
100
HAGO
Liquid
665
3.30
309.00
-
-
5.74
390.00
-
H
12.13
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
10"
HFO
011
018002
101CL2P
10"-HFO-011027004-103CL2P-H
011-C-0002
-
-
H
100
HAGO
Liquid
665
3.40
309.00
-
-
4.92
390.00
-
H
10.40
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
8"
HFO
011
018002
101CL2P
Reducer
10"-HFO-011018002-101CL2P-H
-
-
H
100
HAGO
Liquid
665
3.40
309.00
-
-
4.92
390.00
-
H
10.40
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
4"
HFO
011
018002
101CL2P
4"-HFO-011027004-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
665
3.40
309.00
-
-
4.92
390.00
-
H
10.40
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
3/4"
HFO
011
018003
103CL2P
10"-HFO-011027004-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
3/4"
HFO
011
018003
103CL2P
Insul Brk
Reducer
-
-
P
40
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
3/4"
HFO
011
018003
103CL2P
3/4"-HFO-011018003-103CL2P-P
Blind flange
-
-
P
40
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
2"
HFO
011
018003
103CL2P
Reducer
2"-CLD-011018310-101CH2S-P
-
-
P
50
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
3/4"
HFO
011
018003
103CL2P
10"-HFO-011027004-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
3/4"
HFO
011
018003
103CL2P
Insul Brk
3/4"-HFO-011018003-103CL2P-P
-
-
P
40
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
3/4"
HFO
011
018006
101CL2P
011-LG-0017
3/4"-LFL-011018304-101CH2F-N
-
-
P
40
HAGO
Gas
-
1.60
309.00
-
-
4.10
390.00
-
H
8.66
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
3/4"
HFO
011
018006
101CL2P
3/4"-HFO-011018006-101CL2P-P
Blind flange
-
-
P
40
HAGO
Gas
-
1.60
309.00
-
-
4.10
390.00
-
H
8.66
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
3/4"
HFO
011
018007
101CL2P
011-LG-0017
Reducer
-
-
P
40
HAGO
Liquid
665
3.08
309.00
-
-
5.58
390.00
-
H
11.79
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
3/4"
HFO
011
018007
101CL2P
3/4"-HFO-011018007-101CL2P-P
Blind flange
-
-
P
40
HAGO
Liquid
665
3.08
309.00
-
-
5.58
390.00
-
H
11.79
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
2"
HFO
011
018007
101CL2P
Reducer
2"-CLD-011018304-101CH2S-P
-
-
P
50
HAGO
Liquid
665
3.08
309.00
-
-
5.58
390.00
-
H
11.79
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
20"
HFO
011
018101
103CL4P
011-C-0002
SA-JER-DS011-TRJR-480066
S
33.7
H
100
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
2"
HFO
011
018101
103CL4P
011-LT-0124
011-C-0002
-
-
H
75
ATM. RESIDUE
Liquid
807
1.00
354.00
-
-
3.50
390.00
-
H
7.40
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
2"
HFO
011
018101
103CL4P
011-LT-0124
011-C-0002
-
-
H
75
ATM. RESIDUE
Liquid
807
1.00
354.00
-
-
3.50
390.00
-
H
7.40
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
2"
HFO
011
018101
103CL4P
011-C-0002
011-LT-0125
-
-
H
75
ATM. RESIDUE
Liquid
807
1.00
354.00
-
-
3.50
390.00
-
H
7.40
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
2"
HFO
011
018101
103CL4P
011-C-0002
011-LT-0125
-
-
H
75
ATM. RESIDUE
Liquid
807
1.00
354.00
-
-
3.50
390.00
-
H
7.40
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
-
HFO
011
018101
103CL4P
011-C-0002
TRIM
-
-
H
100
ATM. RESIDUE
Liquid
807
1.00
354.00
-
-
3.50
390.00
-
Visual Test
0.00
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
20"
HFO
011
018101
103CL4P
SA-JER-DS011-TRJR-480044
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
20"
HFO
011
018101
103CL4P
20"-HFO-011018101-103CL4P-S
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
18"
HFO
011
018101
103CL4P
Reducer
18"-HFO-011027102-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
18"
HFO
011
018101
103CL4P
Reducer
18"-HFO-011027101-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
3/4"
HFO
011
018102
103CL4P
011-LG-0019
Reducer
S
33.7
H
65
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
5.20
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
1"
HFO
011
018102
103CL4P
Reducer
Reducer
S
33.7
H
65
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
5.20
390.00
-
H
10.99
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
1"
HFO
011
018102
103CL4P
1"-HFO-011018102-103CL4P-S
Blind flange
S
33.7
H
65
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
5.20
390.00
-
H
10.99
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480044
2"
HFO
011
018102
103CL4P
Reducer
2"-CLD-011018312-101CH2S-P
S
33.7
H
75
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
5.20
390.00
-
H
10.99
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
6"
HFO
011
018105
103CL4P
011-C-0002
6"-OLW-011018301-101CS1P-N
S
33.7
H
100
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
5.20
390.00
-
H
10.99
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200 ºC
NOTE 6
if insulated N or Q SA-JER-DS011-TRJR-480044
-
HFO
011
018601
103CL2P
011-C-0002
TRIM
-
-
H
-
-
-
-
1.60
354.00
-
-
4.10
390.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480052
10"
HFO
011
022001
103CL2P
14"-HFO-011098001-103CL2P-H
10"-HFO-011022001-103CL2P-H
-
-
H
100
HAGO
Liquid
685
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
8"
HFO
011
022001
103CL2P
8"-HFO-011022001-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
685
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
3/4"
HFO
011
022001
103CL2P
10"-HFO-011022001-103CL2P-H
011-PDT-0046
-
-
H
65
HAGO
Liquid
685
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
10"
HFO
011
022001
103CL2P
Reducer
10"-HFO-011022001-103CL2P-H
-
-
H
100
HAGO
Liquid
685
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
10"
HFO
011
022001
103CL2P
10"-HFO-011022001-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
685
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
Reducer
Reducer
-
-
H
100
HAGO
Liquid
685
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
100
685
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
if NOT insulated C or Q
SA-JER-DS011-TRJR-480052
8"
HFO
011
022001
103CL2P
SA-JER-DS011-TRJR-480052
10"
HFO
011
022001
103CL2P
Reducer
10"-HFO-011022001-103CL2P-H
-
HAGO
Liquid
SA-JER-DS011-TRJR-480052
10"
HFO
011
022001
103CL2P
10"-HFO-011022001-103CL2P-H
14"-HFO-011022002-103CL2P-H
-
-
H
100
HAGO
Liquid
685
9.18
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
8"
HFO
011
022001
103CL2P
Reducer
8"-HFO-011022001-103CL2P-H
-
-
H
100
HAGO
Liquid
685
9.18
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
10"
HFO
011
022001
103CL2P
10"-HFO-011022001-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
685
9.18
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
3/4"
HFO
011
022001
103CL2P
10"-HFO-011022001-103CL2P-H
011-PDT-0046
-
-
H
65
HAGO
Liquid
685
9.18
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
18"
HFO
011
022002
103CL2P
011-E-0022
Reducer
-
-
H
100
HAGO
Liquid
697
9.90
272.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
14"
HFO
011
022002
103CL2P
Reducer
Reducer
-
-
H
100
HAGO
Liquid
697
9.90
272.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
1/2"
HFO
011
022002
103CL2P
011-FE-0125
011-FT-0125
-
-
H
40
HAGO
Liquid
697
9.90
272.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
14"
HFO
011
022002
103CL2P
14"-HFO-011022002-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
697
9.90
272.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
12"
HFO
011
022002
103CL2P
Reducer
12"-HFO-011022002-103CL2P-H
-
-
H
100
HAGO
Liquid
697
9.90
272.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
1/2"
HFO
011
022002
103CL2P
011-FE-0125
011-FT-0125
-
-
H
40
HAGO
Liquid
697
9.90
272.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
14"
HFO
011
022002
103CL2P
SA-JER-DS011-TRJR-480052
Reducer
-
-
H
100
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
14"
HFO
011
022002
103CL2P
14"-HFO-011022002-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
12"
HFO
011
022002
103CL2P
Reducer
12"-HFO-011022002-103CL2P-H
-
-
H
100
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
3/4"
HFO
011
022002
103CL2P
14"-HFO-011022002-103CL2P-H
011-PDT-0146
-
-
H
65
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
12"
HFO
011
022002
103CL2P
Reducer
Reducer
-
-
H
100
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
14"
HFO
011
022002
103CL2P
Reducer
14"-HFO-011022002-103CL2P-H
-
-
H
100
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
14"
HFO
011
022002
103CL2P
14"-HFO-011022002-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
697
8.80
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
12"
HFO
011
022002
103CL2P
12"-HFO-011022002-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
697
8.80
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
14"
HFO
011
022002
103CL2P
Reducer
14"-HFO-011022002-103CL2P-H
-
-
H
100
HAGO
Liquid
697
8.80
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
10"
HFO
011
022002
103CL2P
Reducer
Reducer
-
-
H
100
HAGO
Liquid
697
8.80
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
022002
103CL2P
10"-HFO-011022002-103CL2P-H
Blind flange
-
-
H
65
HAGO
Liquid
697
8.80
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
3/4"
HFO
011
022002
103CL2P
2"-HFO-011022002-103CL2P-P
Blind flange
-
-
H
65
HAGO
Liquid
697
8.80
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
022002
103CL2P
2"-FLO-011014307-101CS1P-N
Insul Brk
-
-
H
65
HAGO
Liquid
697
8.80
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
022002
103CL2P
10"-HFO-011022002-103CL2P-H
Blind flange
-
-
H
65
HAGO
Liquid
697
8.80
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
10"
HFO
011
022002
103CL2P
14"-HFO-011022002-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
697
8.80
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
3/4"
HFO
011
022002
103CL2P
2"-HFO-011022002-103CL2P-P
Blind flange
-
-
H
65
HAGO
Liquid
697
8.80
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
022002
103CL2P
Insul Brk
10"-HFO-011022002-103CL2P-H
-
-
H
65
HAGO
Liquid
697
8.80
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
022002
103CL2P
2"-FLO-011014308-101CS1P-N
Insul Brk
-
-
H
65
HAGO
Liquid
697
8.80
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
2"
HFO
011
022002
103CL2P
Insul Brk
10"-HFO-011022002-103CL2P-H
-
-
H
65
HAGO
Liquid
697
8.80
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
12"
HFO
011
022002
103CL2P
Reducer
011-E-0017-A/B
-
-
H
100
HAGO
Liquid
697
8.80
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480026
12"
HFO
011
022002
103CL2P
Reducer
011-E-0017-B
-
-
H
100
HAGO
Liquid
697
8.80
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
12"
HFO
011
022002
103CL2P
Reducer
Reducer
-
-
H
100
HAGO
Liquid
697
9.90
272.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
14"
HFO
011
022002
103CL2P
Reducer
14"-HFO-011022002-103CL2P-H
-
-
H
100
HAGO
Liquid
697
9.90
272.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
14"
HFO
011
022002
103CL2P
14"-HFO-011022002-103CL2P-H
SA-JER-DS011-TRJR-480026
-
-
H
100
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
14"
HFO
011
022002
103CL2P
Reducer
14"-HFO-011022002-103CL2P-H
-
-
H
100
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
2"
HFO
011
022002
103CL2P
14"-HFO-011022002-103CL2P-H
011-TT-0124
-
-
H
65
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
12"
HFO
011
022002
103CL2P
12"-HFO-011022002-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
697
9.18
272.00
-
170.00
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
3/4"
HFO
011
022003
103CL2P
14"-HFO-011022002-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
683
9.90
272.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
3/4"
HFO
011
022003
103CL2P
Insul Brk
Reducer
-
-
P
40
HAGO
Liquid
683
9.90
272.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
3/4"
HFO
011
022003
103CL2P
3/4"-HFO-011022003-103CL2P-P
Blind flange
-
-
P
40
HAGO
Liquid
683
9.90
272.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
2"
HFO
011
022003
103CL2P
Reducer
2"-CLD-011022304-101CH2S-P
-
-
P
40
HAGO
Liquid
683
9.90
272.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
3/4"
HFO
011
022003
103CL2P
14"-HFO-011022002-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
683
9.90
272.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
3/4"
HFO
011
022003
103CL2P
Insul Brk
3/4"-HFO-011022003-103CL2P-P
-
-
P
40
HAGO
Liquid
683
9.90
272.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
4"
HFO
011
022004
103CL2P
14"-HFO-011022002-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
697
9.90
272.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
4"
HFO
011
022004
103CL2P
Insul Brk
4"-CLD-011022303-101CH2S-P
-
-
P
50
HAGO
Liquid
697
9.90
272.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
3/4"
HFO
011
022004
103CL2P
4"-HFO-011022004-103CL2P-P
Blind flange
-
-
P
40
HAGO
Liquid
697
9.90
272.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
3/4"
HFO
011
022005
103CL2P
10"-HFO-011022001-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
685
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
3/4"
HFO
011
022005
103CL2P
Insul Brk
Reducer
-
-
P
40
HAGO
Liquid
685
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
3/4"
HFO
011
022005
103CL2P
3/4"-HFO-011022005-103CL2P-P
Blind flange
-
-
P
40
HAGO
Liquid
685
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
Page 85 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
INSULATION (NOTE 2)
TYPE
FLUID
THICKNESS (mm)
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480052
2"
HFO
011
022005
103CL2P
Reducer
2"-CLD-011022306-101CH2S-P
-
-
P
50
HAGO
Liquid
685
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480056
10"
HFO
011
024001
101CL2P
28"-HFO-011018001-101CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
665
3.30
309.00
-
-
5.74
390.00
-
H
12.13
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
8"
HFO
011
024001
101CL2P
10"-HFO-011024001-101CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
665
3.30
309.00
-
-
5.74
390.00
-
H
12.13
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
6"
HFO
011
024001
101CL2P
Reducer
6"-HFO-011024015-101CL2P-H
-
-
H
100
HAGO
Liquid
665
3.30
309.00
-
-
5.74
390.00
-
H
12.13
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
6"
HFO
011
024001
101CL2P
Reducer
Reducer
-
-
H
100
HAGO
Liquid
665
3.30
309.00
-
-
5.74
390.00
-
H
12.13
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
10"
HFO
011
024001
101CL2P
Reducer
10"-HFO-011024015-101CL2P-H
-
-
H
100
HAGO
Liquid
665
3.30
309.00
-
-
5.74
390.00
-
H
12.13
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
12"
HFO
011
024002
101CL2P
011-C-0006
SA-JER-DS011-TRJR-480044
-
-
H
100
HAGO
Gas
-
1.30
305.00
-
-
3.90
370.00
-
H
7.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
12"-HFO-011024002-101CL2P-H
011-TT-0127
-
-
H
65
HAGO
Gas
-
1.30
305.00
-
-
3.90
370.00
-
H
7.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
65
-
1.30
305.00
-
-
3.90
370.00
-
H
7.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
2"
HFO
011
024002
101CL2P
SA-JER-DS011-TRJR-480056
3/4"
HFO
011
024002
101CL2P
12"-HFO-011024002-101CL2P-H
011-PI-0053
-
HAGO
Gas
SA-JER-DS011-TRJR-480044
12"
HFO
011
024002
101CL2P
SA-JER-DS011-TRJR-480056
Reducer
-
-
H
100
HAGO
Gas
-
1.30
305.00
-
-
3.90
370.00
-
H
7.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
12"
HFO
011
024002
101CL2P
12"-HFO-011024002-101CL2P-H
Reducer
-
-
H
100
HAGO
Gas
-
1.30
305.00
-
-
3.90
370.00
-
H
7.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
10"
HFO
011
024002
101CL2P
Reducer
011-C-0002
-
-
H
100
HAGO
Gas
-
1.30
305.00
-
-
3.90
370.00
-
H
7.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
10"
HFO
011
024002
101CL2P
Reducer
011-C-0002
-
-
H
100
HAGO
Gas
-
1.30
305.00
-
-
3.90
370.00
-
H
7.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
12"
HFO
011
024003
103CL2P
011-ZV-0080
SA-JER-DS011-TRJR-480057
-
-
H
100
HAGO
Liquid
690
2.01
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
12"-HFO-011024003-103CL2P-H
011-TT-0128
-
-
H
65
HAGO
Liquid
690
2.01
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
100
690
2.01
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
2"
HFO
011
024003
103CL2P
SA-JER-DS011-TRJR-480057
12"
HFO
011
024003
103CL2P
SA-JER-DS011-TRJR-480056
12"-HFO-011024004-103CL2P-H
-
HAGO
Liquid
SA-JER-DS011-TRJR-480057
12"
HFO
011
024003
103CL2P
12"-HFO-011024003-103CL2P-H
12"-HFO-011024005-103CL2P-H
-
-
H
100
HAGO
Liquid
690
2.01
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480057
12"
HFO
011
024004
103CL2P
12"-HFO-011024003-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
690
2.01
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480057
3/4"
HFO
011
024004
103CL2P
12"-HFO-011024004-103CL2P-H
011-PI-0232
-
-
H
65
HAGO
Liquid
690
2.01
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480057
2"
HFO
011
024004
103CL2P
12"-HFO-011024004-103CL2P-H
UC
-
-
H
65
HAGO
Liquid
690
2.01
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480057
3/4"
HFO
011
024004
103CL2P
12"-HFO-011024004-103CL2P-H
011-PI-0364
-
-
H
65
HAGO
Liquid
690
2.01
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480057
6"
HFO
011
024004
103CL2P
Reducer
011-G-0013-A
-
-
H
100
HAGO
Liquid
690
2.01
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480057
12"
HFO
011
024005
103CL2P
12"-HFO-011024003-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
690
2.01
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480057
3/4"
HFO
011
024005
103CL2P
12"-HFO-011024005-103CL2P-H
011-PI-0233
-
-
H
65
HAGO
Liquid
690
2.01
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480057
3/4"
HFO
011
024005
103CL2P
12"-HFO-011024005-103CL2P-H
011-PI-0365
-
-
H
65
HAGO
Liquid
690
2.01
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480057
2"
HFO
011
024005
103CL2P
12"-HFO-011024005-103CL2P-H
UC
-
-
H
65
HAGO
Liquid
690
2.01
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480057
6"
HFO
011
024005
103CL2P
Reducer
011-G-0013-B
-
-
H
100
HAGO
Liquid
690
2.01
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480057
3"
HFO
011
024006
103CL2P
011-G-0013-A
Reducer
-
-
H
100
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480057
6"
HFO
011
024006
103CL2P
Reducer
SA-JER-DS011-TRJR-480017
-
-
H
100
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480057
3/4"
HFO
011
024006
103CL2P
6"-HFO-011024006-103CL2P-H
011-PI-0055
-
-
H
65
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480057
3/4"
HFO
011
024006
103CL2P
6"-HFO-011024006-103CL2P-H
6"-HFO-011024006-103CL2P-H
-
-
H
65
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
6"
HFO
011
024006
103CL2P
SA-JER-DS011-TRJR-480057
6"-HFO-011024006-103CL2P-H
-
-
H
100
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
6"
HFO
011
024006
103CL2P
6"-HFO-011024006-103CL2P-H
6"-HFO-011024006-103CL2P-H
-
-
H
100
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
6"
HFO
011
024006
103CL2P
6"-HFO-011024006-103CL2P-H
011-PDT-0110
-
-
H
100
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
6"
HFO
011
024006
103CL2P
6"-HFO-011024006-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
690
13.50
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
6"
HFO
011
024006
103CL2P
6"-HFO-011024006-103CL2P-H
6"-HFO-011024006-103CL2P-H
-
-
H
100
HAGO
Liquid
690
13.50
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
2"
HFO
011
024006
103CL2P
6"-HFO-011024006-103CL2P-H
011-TT-0211
-
-
H
65
HAGO
Liquid
690
13.50
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480017
8"
HFO
011
024006
103CL2P
Reducer
011-E-0012-A
-
-
H
100
HAGO
Liquid
690
13.50
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480057
3/4"
HFO
011
024006
103CL2P
6"-HFO-011024006-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480057
3/4"
HFO
011
024006
103CL2P
Insul Brk
End
-
-
P
25
HAGO
Liquid
690
0.00
27.00
-
-
0.00
60.00
-
H
0.00
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480057
3"
HFO
011
024007
103CL2P
011-G-0013-B
Reducer
-
-
H
100
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480057
6"
HFO
011
024007
103CL2P
Reducer
6"-HFO-011024006-103CL2P-H
-
-
H
100
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480057
3/4"
HFO
011
024007
103CL2P
6"-HFO-011024007-103CL2P-H
6"-HFO-011024007-103CL2P-H
-
-
H
65
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480057
3/4"
HFO
011
024007
103CL2P
6"-HFO-011024007-103CL2P-H
011-PI-0056
-
-
H
65
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480057
3/4"
HFO
011
024007
103CL2P
6"-HFO-011024007-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480057
3/4"
HFO
011
024007
103CL2P
Insul Brk
End
-
-
P
25
HAGO
Liquid
690
0.00
27.00
-
-
0.00
60.00
-
H
0.00
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480057
1-1/2"
HFO
011
024008
103CL2P
6"-HFO-011024006-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480057
1-1/2"
HFO
011
024008
103CL2P
Insul Brk
Reducer
SA-JER-DS011-TRJR-480057
3/4"
HFO
011
024008
103CL2P
SA-JER-DS011-TRJR-480057
2"
HFO
011
024008
103CL2P
Reducer
SA-JER-DS011-TRJR-480057
1-1/2"
HFO
011
024008
103CL2P
SA-JER-DS011-TRJR-480057
1-1/2"
HFO
011
024008
SA-JER-DS011-TRJR-480057
3/4"
HFO
011
SA-JER-DS011-TRJR-480057
1"
HFO
SA-JER-DS011-TRJR-480057
1-1/2"
SA-JER-DS011-TRJR-480057 SA-JER-DS011-TRJR-480057
-
-
P
50
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
40
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
2"-CLD-011024302-101CH2S-P
-
-
P
50
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
12"-HFO-011024004-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
103CL2P
Insul Brk
1-1/2"-HFO-011024008-103CL2PP
-
-
P
50
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
024008
103CL2P
011-G-0013-A
Reducer
-
-
P
40
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
011
024008
103CL2P
Reducer
1-1/2"-HFO-011024008-103CL2PP
-
-
P
40
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
HFO
011
024009
103CL2P
6"-HFO-011024007-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
1-1/2"
HFO
011
024009
103CL2P
Insul Brk
Reducer
3/4"
HFO
011
024009
103CL2P
SA-JER-DS011-TRJR-480057
2"
HFO
011
024009
103CL2P
Reducer
SA-JER-DS011-TRJR-480057
1-1/2"
HFO
011
024009
103CL2P
SA-JER-DS011-TRJR-480057
1-1/2"
HFO
011
024009
103CL2P
SA-JER-DS011-TRJR-480057
3/4"
HFO
011
024009
103CL2P
1-1/2"-HFO-011024008-103CL2P- 3/4"-OLW-011024303-101CS1PP N
-
-
P
50
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
40
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
2"-CLD-011024303-101CH2S-P
-
-
P
50
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
12"-HFO-011024005-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
Insul Brk
1-1/2"-HFO-011024009-103CL2PP
-
-
P
50
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
011-G-0013-B
Reducer
-
-
P
40
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
40
HAGO
Liquid
690
13.66
295.00
-
-
20.00
325.00
-
H
35.86
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
1-1/2"-HFO-011024009-103CL2P- 3/4"-OLW-011024304-101CS1PP N
SA-JER-DS011-TRJR-480057
1"
HFO
011
024009
103CL2P
Reducer
1-1/2"-HFO-011024009-103CL2PP
SA-JER-DS011-TRJR-480056
3"
HFO
011
024010
101CL2P
011-C-0006
3"-OLW-011024302-101CS1P-N
-
-
H
100
HAGO
Liquid
690
2.01
295.00
-
-
4.81
370.00
-
H
8.85
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
3/4"
HFO
011
024012
101CL2P
011-LG-0041-B
3/4"-LFL-011024302-101CH2F-N
-
-
P
40
HAGO
Gas
-
1.40
295.00
-
-
4.00
370.00
-
H
7.36
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
3/4"
HFO
011
024012
101CL2P
3/4"-HFO-011024012-101CL2P-P
Blind flange
-
-
P
40
HAGO
Gas
-
1.40
295.00
-
-
4.00
370.00
-
H
7.36
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
3/4"
HFO
011
024012
101CL2P
011-LG-0041-A
3/4"-HFO-011024012-101CL2P-P
-
-
P
40
HAGO
Gas
-
1.40
295.00
-
-
4.00
370.00
-
H
7.36
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
12"
HFO
011
024013
101CL2P
011-C-0006
011-ZV-0080
-
-
H
100
HAGO
Liquid
690
2.01
295.00
-
-
4.81
370.00
-
H
8.85
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
2"
HFO
011
024014
103CL2P
12"-HFO-011024013-101CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
690
2.01
295.00
-
-
4.81
370.00
-
H
8.85
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
2"
HFO
011
024014
103CL2P
Insul Brk
2"-CLD-011024301-101CH2S-P
-
-
P
50
HAGO
Liquid
690
2.01
295.00
-
-
4.81
370.00
-
H
8.85
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
3/4"
HFO
011
024014
103CL2P
2"-HFO-011024014-103CL2P-P
3/4"-OLW-011024301-101CS1PN
-
-
P
40
HAGO
Liquid
690
2.01
295.00
-
-
4.81
370.00
-
H
8.85
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
3/4"
HFO
011
024014
103CL2P
011-LG-0041-A
2"-HFO-011024014-103CL2P-P
-
-
P
40
HAGO
Liquid
690
2.01
295.00
-
-
4.81
370.00
-
H
8.85
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
3/4"
HFO
011
024014
103CL2P
011-LG-0041-B
3/4"-HFO-011024014-103CL2P-P
-
-
P
40
HAGO
Liquid
690
2.01
295.00
-
-
4.81
370.00
-
H
8.85
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
10"
HFO
011
024015
101CL2P
10"-HFO-011024001-101CL2P-H
011-C-0006
-
-
H
100
HAGO
Liquid
665
2.40
309.00
-
-
4.00
370.00
-
H
7.36
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
8"
HFO
011
024015
101CL2P
Reducer
10"-HFO-011024015-101CL2P-H
-
-
H
100
HAGO
Liquid
665
2.40
309.00
-
-
4.00
370.00
-
H
7.36
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
6"
HFO
011
024015
101CL2P
6"-HFO-011024001-101CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
665
2.40
309.00
-
-
4.00
370.00
-
H
7.36
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
2"
HFO
011
024016
101CL2P
10"-HFO-011024001-101CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
665
3.30
309.00
-
-
5.74
390.00
-
H
12.13
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
2"
HFO
011
024016
101CL2P
Insul Brk
2"-CLD-011024304-101CH2S-P
-
-
P
50
HAGO
Liquid
665
3.30
309.00
-
-
5.74
390.00
-
H
12.13
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
3/4"
HFO
011
024016
101CL2P
2"-HFO-011024016-101CL2P-P
Blind flange
-
-
P
40
HAGO
Liquid
665
3.30
309.00
-
-
5.74
390.00
-
H
12.13
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
2"
HFO
011
024016
101CL2P
10"-HFO-011024001-101CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
665
3.30
309.00
-
-
5.74
390.00
-
H
12.13
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
2"
HFO
011
024016
101CL2P
Insul Brk
2"-HFO-011024016-101CL2P-P
-
-
P
50
HAGO
Liquid
665
3.30
309.00
-
-
5.74
390.00
-
H
12.13
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
2"
HFO
011
024018
101CL2P
UC
011-C-0006
-
-
P
50
HAGO
Liquid
690
1.30
305.00
-
-
3.90
370.00
-
H
7.17
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: 7 barg+FV@290ºC.
SA-JER-DS011-TRJR-480056
3/4"
HFO
011
024018
101CL2P
2"-HFO-011024018-101CL2P-P
Plug
-
-
P
40
HAGO
Liquid
690
1.30
305.00
-
-
3.90
370.00
-
H
7.17
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: 7 barg+FV@290ºC.
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150 ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150 ºC
if insulated N or Q SA-JER-DS011-TRJR-480056
-
HFO
011
024601
101CL2P
011-C-0006
TRIM
-
-
H
-
-
-
-
1.40
295.00
-
-
4.00
370.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480056
2"
HFO
011
024601
101CL2P
011-C-0006
011-LG-0041-A
-
-
H
65
-
-
-
1.40
295.00
-
-
4.00
370.00
-
H
7.36
NFS
YES
SA-JER-DS011-TRJR-380001
if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q
Page 86 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7) if insulated N or Q
SA-JER-DS011-TRJR-480056
2"
HFO
011
024601
101CL2P
011-C-0006
011-LG-0041-B
-
-
H
65
-
-
-
1.40
295.00
-
-
4.00
370.00
-
H
7.36
NFS
YES
SA-JER-DS011-TRJR-480056
2"
HFO
011
024601
101CL2P
011-C-0006
011-LG-0041-B
-
-
H
65
-
-
-
1.40
295.00
-
-
4.00
370.00
-
H
7.36
NFS
YES
SA-JER-DS011-TRJR-480056
2"
HFO
011
024601
101CL2P
011-C-0006
Gate valve
-
-
H
65
-
-
-
1.40
295.00
-
-
4.00
370.00
-
H
7.36
NFS
YES
SA-JER-DS011-TRJR-480056
2"
HFO
011
024601
101CL2P
011-C-0006
Gate valve
-
-
H
65
-
-
-
1.40
295.00
-
-
4.00
370.00
-
H
7.36
NFS
YES
SA-JER-DS011-TRJR-480056
2"
HFO
011
024601
101CL2P
011-C-0006
011-LG-0041-A
-
-
H
65
-
-
-
1.40
295.00
-
-
4.00
370.00
-
H
7.36
NFS
YES
SA-JER-DS011-TRJR-480056
2"
HFO
011
024601
101CL2P
011-C-0006
011-PI-0054
-
-
H
65
-
-
-
1.40
295.00
-
-
4.00
370.00
-
H
7.36
NFS
YES
SA-JER-DS011-TRJR-480056
-
HFO
011
024602
103CL2P
011-C-0006
TRIM
-
-
H
-
-
-
-
1.40
295.00
-
-
4.00
370.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480056
3"
HFO
011
024602
103CL2P
011-C-0006
Blind flange
-
-
H
100
-
-
-
1.40
295.00
-
-
4.00
370.00
-
H
7.36
NFS
YES
SA-JER-DS011-TRJR-480061
6"
HFO
011
025001
103CS1P
011-A-0004
SA-JER-DS011-TRJR-480062
-
-
P
25
HAGO
Liquid
845
9.63
65.00
-
-
20.00
130.00
-
H
30.00
NFS
By Code
SA-JER-DS011-TRJR-480061
6"
HFO
011
025001
103CS1P
011-A-0004
6"-HFO-011025001-103CS1P-P
-
-
P
25
HAGO
Liquid
845
9.63
65.00
-
-
20.00
130.00
-
H
30.00
NFS
By Code
SA-JER-DS011-TRJR-480062
6"
HFO
011
025001
103CS1P
SA-JER-DS011-TRJR-480061
011-E-0035
-
-
P
25
HAGO
Liquid
845
9.63
65.00
-
-
20.00
130.00
-
H
30.00
NFS
SA-JER-DS011-TRJR-480062
6"
HFO
011
025002
103CS1P
011-E-0035
6"-HFO-011025002-103CS1P-N
-
-
N
-
HAGO
Liquid
853
10.15
50.00
-
-
20.00
80.00
-
H
30.00
SA-JER-DS011-TRJR-480062
6"
HFO
011
025002
103CS1P
6"-HFO-011025002-103CS1P-N
Reducer
-
-
N
-
HAGO
Liquid
853
10.15
50.00
-
-
28.30
80.00
-
H
42.45
SA-JER-DS011-TRJR-480136
6"
HFO
011
025002
103CS1P
SA-JER-DS011-TRJR-480062
6"-SLP-011099001-103CS1P-S
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
SA-JER-DS011-TRJR-480062
4"
HFO
011
025002
103CS1P
Reducer
Reducer
-
-
N
-
HAGO
Liquid
853
10.15
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
SA-JER-DS011-TRJR-480062
6"
HFO
011
025002
103CS1P
Reducer
6"-HFO-011025002-103CS1P-N
-
-
N
-
HAGO
Liquid
853
10.15
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
SA-JER-DS011-TRJR-480062
6"
HFO
011
025002
103CS1P
6"-HFO-011025002-103CS1P-N
6"-HFO-011025002-103CS1P-N
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
SA-JER-DS011-TRJR-480062
6"
HFO
011
025002
103CS1P
6"-DIE-011025003-103CS1P-N
SA-JER-DS011-TRJR-480136
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
SA-JER-DS011-TRJR-480062
4"
HFO
011
025004
103CS1P
6"-HFO-011025002-103CS1P-N
011-SP-0036
-
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150 ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150 ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150 ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150 ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150 ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150 ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150 ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150 ºC
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. MAX. TEMPERATURE FOR OTHER CASES: 50ºC.
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. MAX. TEMPERATURE FOR OTHER CASES: 50ºC.
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q
-
N
-
HAGO
Liquid
853
10.15
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6 NOTE 6 MAX. TEMPERATURE FOR OTHER CASES: 50°C NOTES 6,10 MAX. TEMPERATURE FOR OTHER CASES: 50°C NOTE 10 MAX. TEMPERATURE FOR OTHER CASES: 50°C NOTE 10
SA-JER-DS011-TRJR-480062
4"
HFO
011
025004
103CS1P
011-SP-0036
Reducer
-
-
N
-
HAGO
Liquid
853
10.15
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480062
1-1/2"
HFO
011
025004
103CS1P
Reducer
011-PZV-0068-B
-
-
N
-
HAGO
Liquid
853
10.15
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480062
2"
HFO
011
025004
103CS1P
4"-HFO-011025004-103CS1P-N
4"-LFL-011025304-101CH2F-N
-
-
N
-
HAGO
Liquid
853
10.15
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480062
4"
HFO
011
025004
103CS1P
2"-HFO-011025004-103CS1P-N
011-SP-0036
-
-
N
-
HAGO
Liquid
853
10.15
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480062
4"
HFO
011
025004
103CS1P
011-SP-0036
Reducer
-
-
N
-
HAGO
Liquid
853
10.15
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480062
1-1/2"
HFO
011
025004
103CS1P
Reducer
011-PZV-0068-A
-
-
N
-
HAGO
Liquid
853
10.15
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480062
3/4"
HFO
011
025005
103CS1P
6"-HFO-011025002-103CS1P-N
Reducer
-
-
N
-
HAGO
Liquid
853
10.15
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480062
2"
HFO
011
025005
103CS1P
Reducer
2"-CLD-011025305-101CH2S-P
-
-
N
-
HAGO
Liquid
853
10.15
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480062
3/4"
HFO
011
025006
103CS1P
6"-HFO-011025002-103CS1P-N
Reducer
-
-
N
-
HAGO
Liquid
853
10.15
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480062
2"
HFO
011
025006
103CS1P
Reducer
2"-CLD-011025306-101CH2S-P
-
-
N
-
HAGO
Liquid
853
10.15
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480062
3/4"
HFO
011
025006
103CS1P
6"-HFO-011025002-103CS1P-N
3/4"-HFO-011025006-103CS1P-N
-
-
N
-
HAGO
Liquid
853
10.15
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480062
3/4"
HFO
011
025007
103CS1P
6"-HFO-011025002-103CS1P-N
011-SC-0020
-
-
N
-
HAGO
Liquid
853
10.15
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480062
3/4"
HFO
011
025008
103CS1P
011-SC-0020
6"-HFO-011025002-103CS1P-N
-
-
N
-
HAGO
Liquid
854
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480061
3/4"
HFO
011
025011
103CS1P
6"-HFO-011001001-103CS1P-P
3/4"-LFL-011025303-101CH2F-N
-
-
P
25
HAGO
Gas
-
11.44
95.00
-
-
20.00
205.00
-
H
30.02
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480061
3/4"
HFO
011
025011
103CS1P 3/4"-HFO-011025011-103CS1P-P
Plug
-
-
P
25
HAGO
Gas
-
11.44
95.00
-
-
20.00
205.00
-
H
30.02
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480061
1-1/2"
HFO
011
025012
103CS1P
Reducer
-
-
P
25
HAGO
Liquid
845
9.63
65.00
-
-
20.00
130.00
-
H
30.00
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480061
1-1/2"
HFO
011
025012
103CS1P
-
-
P
25
HAGO
Liquid
845
9.63
65.00
-
-
20.00
130.00
-
H
30.00
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480061
2"
HFO
011
025012
103CS1P
Reducer
2"-CLD-011025316-101CH2S-P
-
-
P
25
HAGO
Liquid
845
9.63
65.00
-
-
20.00
130.00
-
H
30.00
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
20"
HFO
011
027001
103CL2P
20"-HFO-011018001-101CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
665
3.30
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
3/4"
HFO
011
027001
103CL2P
20"-HFO-011027001-103CL2P-H
011-PI-0362
-
-
H
65
HAGO
Liquid
665
3.30
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
2"
HFO
011
027001
103CL2P
2"-FLO-011027301-101CS1P-N
20"-HFO-011027001-103CL2P-H
-
-
H
65
HAGO
Liquid
665
3.30
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
3/4"
HFO
011
027001
103CL2P
2"-HFO-011027001-103CL2P-H
Plug
-
-
H
65
HAGO
Liquid
665
3.30
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
2"
HFO
011
027001
103CL2P
20"-HFO-011027001-103CL2P-H
Blind flange
-
-
H
65
HAGO
Liquid
665
3.30
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
3/4"
HFO
011
027001
103CL2P
20"-HFO-011027001-103CL2P-H
011-PI-0221
-
-
H
65
HAGO
Liquid
665
3.30
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
14"
HFO
011
027001
103CL2P
Reducer
011-G-0012-A
-
-
H
100
HAGO
Liquid
665
3.30
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
20"
HFO
011
027002
103CL2P
20"-HFO-011018001-101CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
665
3.30
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
3/4"
HFO
011
027002
103CL2P
20"-HFO-011027002-103CL2P-H
011-PI-0363
-
-
H
65
HAGO
Liquid
665
3.30
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
2"
HFO
011
027002
103CL2P
2"-FLO-011027306-101CS1P-N
20"-HFO-011027002-103CL2P-H
-
-
H
65
HAGO
Liquid
665
3.30
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
3/4"
HFO
011
027002
103CL2P
2"-HFO-011027002-103CL2P-H
Plug
-
-
H
65
HAGO
Liquid
665
3.30
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
2"
HFO
011
027002
103CL2P
20"-HFO-011027002-103CL2P-H
Blind flange
-
-
H
65
HAGO
Liquid
665
3.30
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
14"
HFO
011
027002
103CL2P
Reducer
011-G-0012-B
-
-
H
100
HAGO
Liquid
665
3.30
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
3/4"
HFO
011
027002
103CL2P
20"-HFO-011027002-103CL2P-H
011-PI-0221
-
-
H
65
HAGO
Liquid
665
3.30
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
12"
HFO
011
027003
103CL2P
011-G-0012-A
Reducer
-
-
H
100
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
18"
HFO
011
027003
103CL2P
Reducer
18"-HFO-011027003-103CL2P-H
-
-
H
100
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
3/4"
HFO
011
027003
103CL2P
18"-HFO-011027003-103CL2P-H
18"-HFO-011027003-103CL2P-H
-
-
H
65
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
3/4"
HFO
011
027003
103CL2P
18"-HFO-011027003-103CL2P-H
011-PI-0061
-
-
H
65
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
14"
HFO
011
027003
103CL2P
SA-JER-DS011-TRJR-480065
DS111-TRJR-480042
-
-
H
100
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
3/4"
HFO
011
027003
103CL2P
14"-HFO-011027003-103CL2P-H
011-PI-0167
-
-
H
65
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
2"
HFO
011
027003
103CL2P
14"-HFO-011027003-103CL2P-H
Blind flange
-
-
H
65
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
18"
HFO
011
027003
103CL2P
18"-HFO-011027003-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
14"
HFO
011
027003
103CL2P
Reducer
SA-JER-DS011-TRJR-480134
-
-
H
100
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
10"
HFO
011
027004
103CL2P
18"-HFO-011027003-103CL2P-H
SA-JER-DS011-TRJR-480044
-
-
H
100
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
10"
HFO
011
027004
103CL2P
SA-JER-DS011-TRJR-480065
Reducer
-
-
H
100
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
4"
HFO
011
027004
103CL2P
Reducer
4"-HFO-011018002-101CL2P-H
-
-
H
100
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
1/2"
HFO
011
027004
103CL2P
011-FE-0022
011-FT-0022
-
-
H
65
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
011-A-0004
1-1/2"-HFO-011025012-103CS1P- 3/4"-OLW-011025302-101CS1PP N
MAX. TEMPERATURE FOR OTHER CASES: 50°CNOTES 6,10 MAX. TEMPERATURE FOR OTHER CASES: 50°C NOTES 6,10 MAX. TEMPERATURE FOR OTHER CASES: 50°C NOTE 10 MAX. TEMPERATURE FOR OTHER CASES: 50°C NOTE 10
SA-JER-DS011-TRJR-480044
8"
HFO
011
027004
103CL2P
10"-HFO-011027004-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
1/2"
HFO
011
027004
103CL2P
011-FE-0022
011-FT-0022
-
-
H
65
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
6"
HFO
011
027004
103CL2P
Reducer
Reducer
-
-
H
100
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 87 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
INSULATION (NOTE 2)
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
10"-HFO-011018002-101CL2P-H
-
-
H
100
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
Liquid
665
13.20
309.00
-
-
PRESS. (BARG)
340.00
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
-
H
33.39
NFS
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480044
10"
HFO
011
027004
103CL2P
Reducer
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
12"
HFO
011
027005
103CL2P
011-G-0012-B
Reducer
-
-
H
100
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
18"
HFO
011
027005
103CL2P
Reducer
18"-HFO-011027005-103CL2P-H
-
-
H
100
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
3/4"
HFO
011
027005
103CL2P
18"-HFO-011027005-103CL2P-H
011-PI-0062
-
-
H
65
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
3/4"
HFO
011
027005
103CL2P
18"-HFO-011027005-103CL2P-H
18"-HFO-011027005-103CL2P-H
-
-
H
65
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
18"
HFO
011
027005
103CL2P
18"-HFO-011027005-103CL2P-H
18"-HFO-011027003-103CL2P-H
-
-
H
100
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
2"
HFO
011
027006
103CL2P
18"-HFO-011027003-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
2"
HFO
011
027006
103CL2P
Insul Brk
2"-CLD-011027301-101CH2S-P
-
-
P
50
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
2"-HFO-011027006-103CL2P-P
3/4"-OLW-011027001-101CS1PN
-
-
P
40
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
HAGO
18.50
TEMP. (ºC)
STRESS TEMP
SA-JER-DS011-TRJR-380001
YES
N or Q
SA-JER-DS011-TRJR-480065
3/4"
HFO
011
027006
103CL2P
SA-JER-DS011-TRJR-480065
3/4"
HFO
011
027006
103CL2P
14"-HFO-011027001-103CL2P-H 3/4"-HFO-011027006-103CL2P-P
-
-
H
65
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
3/4"
HFO
011
027006
103CL2P
3/4"-HFO-011027006-103CL2P-P
2"-HFO-011027006-103CL2P-P
-
-
P
40
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
2"
HFO
011
027006
103CL2P
20"-HFO-011027001-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
2"
HFO
011
027006
103CL2P
Insul Brk
3/4"-HFO-011027006-103CL2P-P
-
-
P
50
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
3/4"
HFO
011
027006
103CL2P
011-G-0012-A
3/4"-HFO-011027006-103CL2P-P
-
-
P
40
HAGO
Gas
-
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
3/4"
HFO
011
027006
103CL2P
011-G-0012-A
Reducer
-
-
P
40
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
2"
HFO
011
027006
103CL2P
Reducer
3/4"-HFO-011027006-103CL2P-P
-
-
P
50
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
2"
HFO
011
027007
103CL2P
18"-HFO-011027005-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
2"
HFO
011
027007
103CL2P
Insul Brk
2"-CLD-011027302-101CH2S-P
-
-
P
50
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
40
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
3/4"
HFO
011
027007
103CL2P
2"-HFO-011027007-103CL2P-P
3/4"-OLW-011027002-101CS1PN
SA-JER-DS011-TRJR-480065
2"
HFO
011
027007
103CL2P
14"-HFO-011027002-103CL2P-H
2"-HFO-011027007-103CL2P-P
-
-
H
65
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
2"
HFO
011
027007
103CL2P
2"-HFO-011027007-103CL2P-P
2"-HFO-011027007-103CL2P-P
-
-
P
50
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
3/4"
HFO
011
027007
103CL2P
20"-HFO-011027002-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
3/4"
HFO
011
027007
103CL2P
Insul Brk
2"-HFO-011027007-103CL2P-P
-
-
P
40
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
3/4"
HFO
011
027007
103CL2P
011-G-0012-B
2"-HFO-011027007-103CL2P-P
-
-
P
40
HAGO
Gas
-
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
3/4"
HFO
011
027007
103CL2P
011-G-0012-B
Reducer
-
-
P
40
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480065
2"
HFO
011
027007
103CL2P
Reducer
2"-HFO-011027007-103CL2P-P
-
-
P
50
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
18"
HFO
011
027101
103CL4P
18"-HFO-011018101-103CL4P-S
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027101
103CL4P
18"-HFO-011027101-103CL4P-S
011-PI-0366
S
33.7
H
65
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027101
103CL4P
18"-HFO-011027101-103CL4P-S
011-PDT-0035
S
33.7
H
65
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
2"
HFO
011
027101
103CL4P
18"-HFO-011027101-103CL4P-S
UC
S
33.7
H
75
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027101
103CL4P
2"-HFO-011027101-103CL4P-S
Blind flange
S
33.7
H
65
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
2"
HFO
011
027101
103CL4P
2"-FLO-011027302-101CS1P-N
18"-HFO-011027101-103CL4P-S
S
33.7
H
75
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027101
103CL4P
18"-HFO-011027101-103CL4P-S
011-PDT-0035
S
33.7
H
65
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
14"
HFO
011
027101
103CL4P
Reducer
011-G-0014-A
S
33.7
H
100
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
18"
HFO
011
027102
103CL4P
18"-HFO-011018101-103CL4P-S
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027102
103CL4P
2"-HFO-011027102-103CL4P-S
Blind flange
S
33.7
H
65
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027102
103CL4P
18"-HFO-011027102-103CL4P-S
011-PI-0367
S
33.7
H
65
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027102
103CL4P
18"-HFO-011027102-103CL4P-S
011-PDT-0065
S
33.7
H
65
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
2"
HFO
011
027102
103CL4P
18"-HFO-011027102-103CL4P-S
UC
S
33.7
H
75
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
2"
HFO
011
027102
103CL4P
2"-FLO-011027303-101CS1P-N
18"-HFO-011027102-103CL4P-S
S
33.7
H
75
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027102
103CL4P
18"-HFO-011027102-103CL4P-S
011-PDT-0065
S
33.7
H
65
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
14"
HFO
011
027102
103CL4P
Reducer
011-G-0014-B
S
33.7
H
100
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
10"
HFO
011
027103
103CL4P
011-G-0014-A
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
12"
HFO
011
027103
103CL4P
12"-HFO-011027103-103CL4P-S
12"-HFO-011027105-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
12"
HFO
011
027103
103CL4P
Reducer
12"-HFO-011027103-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027103
103CL4P
12"-HFO-011027103-103CL4P-S
12"-HFO-011027103-103CL4P-S
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027103
103CL4P
12"-HFO-011027103-103CL4P-S
011-PI-0063
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480312
12"
HFO
011
027103
103CL4P
SA-JER-DS011-TRJR-480066
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480312
2"
HFO
011
027103
103CL4P
12"-HFO-011027103-103CL4P-S
011-TT-0133
S
33.7
H
75
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480312
6"
HFO
011
027103
103CL4P
Reducer
SA-JER-DS011-TRJR-480067
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
12"
HFO
011
027103
103CL4P
12"-HFO-011027103-103CL4P-S
12"-HFO-011027103-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1/2"
HFO
011
027103
103CL4P
011-FE-0032-A
011-FT-0032-A
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1/2"
HFO
011
027103
103CL4P
011-FE-0032-A
011-FT-0032-A
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1/2"
HFO
011
027103
103CL4P
011-FE-0032-A
011-FT-0032-B
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1/2"
HFO
011
027103
103CL4P
011-FE-0032-A
011-FT-0032-B
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
6"
HFO
011
027103
103CL4P
SA-JER-DS011-TRJR-480312
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
6"
HFO
011
027103
103CL4P
6"-HFO-011027103-103CL4P-S
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
1/2"
HFO
011
027103
103CL4P
011-FE-0034
011-FT-0034-BB
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
1/2"
HFO
011
027103
103CL4P
011-FE-0034
011-FT-0034-BA
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
3"
HFO
011
027103
103CL4P
Reducer
3"-HFO-011028109-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
1/2"
HFO
011
027103
103CL4P
011-FE-0034
011-FT-0034-BC
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
1/2"
HFO
011
027103
103CL4P
011-FE-0034
011-FT-0034-BB
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
1/2"
HFO
011
027103
103CL4P
011-FE-0034
011-FT-0034-BA
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
1/2"
HFO
011
027103
103CL4P
011-FE-0034
011-FT-0034-BC
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
4"
HFO
011
027103
103CL4P
Reducer
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
8"
HFO
011
027103
103CL4P
Reducer
8"-HFO-011028109-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
12"
HFO
011
027103
103CL4P
12"-HFO-011027103-103CL4P-S
SA-JER-DS011-TRJR-480312
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027103
103CL4P
12"-HFO-011027103-103CL4P-S
Blind flange
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
8"
HFO
011
027104
103CL4P
12"-HFO-011027103-103CL4P-S
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
6"
HFO
011
027104
103CL4P
Reducer
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
8"
HFO
011
027104
103CL4P
Reducer
8"-HFO-011027114-101CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
12"
HFO
011
027105
103CL4P
12"-HFO-011027103-103CL4P-S
SA-JER-DS011-TRJR-480103
S
33.7
H
100
ATM. RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480103
12"
HFO
011
027105
103CL4P
SA-JER-DS011-TRJR-480066
12"-HFO-011027105-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480103
12"
HFO
011
027105
103CL4P
12"-HFO-011027105-103CL4P-S
12"-HFO-011039103-103CL4P-S
S
155
H
100
ATM. RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
1"
HFO
011
027105
103CL4P
2"-FLO-011039310-101CS1P-N
12"-HFO-011027105-103CL4P-S
S
33.7
H
65
ATM. RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480103
1"
HFO
011
027105
103CL4P
1"-HFO-011027105-103CL4P-S
Blind flange
S
33.7
H
65
ATM. RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480066
10"
HFO
011
027106
103CL4P
011-G-0014-B
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
12"
HFO
011
027106
103CL4P
Reducer
12"-HFO-011027106-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027106
103CL4P
12"-HFO-011027106-103CL4P-S
011-PI-0064
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027106
103CL4P
12"-HFO-011027106-103CL4P-S
12"-HFO-011027106-103CL4P-S
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
12"
HFO
011
027106
103CL4P
12"-HFO-011027106-103CL4P-S
12"-HFO-011027103-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
2"
HFO
011
027107
103CL4P
12"-HFO-011027103-103CL4P-S
2"-CLD-011027303-101CH2S-P
S
33.7
H
75
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027107
103CL4P
2"-HFO-011027107-103CL4P-S
1"-OLW-011027303-101CS1P-N
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
2"
HFO
011
027107
103CL4P
14"-HFO-011027101-103CL4P-S
2"-HFO-011027107-103CL4P-S
S
33.7
H
75
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027107
103CL4P
011-G-0014-A
2"-HFO-011027107-103CL4P-S
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
3/4"
HFO
011
027107
103CL4P
18"-HFO-011027101-103CL4P-S
2"-HFO-011027107-103CL4P-S
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027107
103CL4P
011-G-0014-A
2"-HFO-011027107-103CL4P-S
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
2"
HFO
011
027108
103CL4P
12"-HFO-011027106-103CL4P-S
2"-CLD-011027304-101CH2S-P
S
33.7
H
75
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027108
103CL4P
2"-HFO-011027108-103CL4P-S
1"-OLW-011027304-101CS1P-N
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
2"
HFO
011
027108
103CL4P
14"-HFO-011027102-103CL4P-S
2"-HFO-011027108-103CL4P-S
S
33.7
H
75
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027108
103CL4P
011-G-0014-B
2"-HFO-011027108-103CL4P-S
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
NOTE 6
Page 88 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
(ºC)
TEST CONDITIONS
MEDIUM (NOTE 5)
PRESS. (BARG)
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6)
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480066
3/4"
HFO
011
027108
103CL4P
18"-HFO-011027102-103CL4P-S
2"-HFO-011027108-103CL4P-S
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027108
103CL4P
011-G-0014-B
2"-HFO-011027108-103CL4P-S
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027110
103CL4P
12"-HFO-011027103-103CL4P-S
011-SC-0043
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
1"
HFO
011
027110
103CL4P
12"-RES-011027003-103CL4P-S
Reducer
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
1/2"
HFO
011
027110
103CL4P
Reducer
SAMPLE COOLER
S
33.7
H
65
VACUUM RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027111
103CL4P
011-SC-0043
18"-HFO-011018101-103CL4P-S
S
33.7
H
65
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
1"
HFO
011
027111
103CL4P
1"-HFO-011027110-103CL4P-S
18"-RES-011018001-103CL4P-S
S
33.7
H
65
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027112
103CL4P
8"-HFO-011027104-103CL4P-S
Reducer
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027112
103CL4P
1"-HFO-011027112-103CL4P-S
Blind flange
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
2"
HFO
011
027112
103CL4P
Reducer
2"-CLD-011027305-101CH2S-P
S
33.7
H
75
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480312
6"
HFO
011
027113
103CL4P
12"-HFO-011027103-103CL4P-S
SA-JER-DS011-TRJR-480067
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
6"
HFO
011
027113
103CL4P
SA-JER-DS011-TRJR-480312
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
1/2"
HFO
011
027113
103CL4P
011-FE-0034
011-FT-0034-AA
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
6"
HFO
011
027113
103CL4P
6"-HFO-011027113-103CL4P-S
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
1/2"
HFO
011
027113
103CL4P
011-FE-0034
011-FT-0034-AC
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
1/2"
HFO
011
027113
103CL4P
011-FE-0034
011-FT-0034-AC
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
1/2"
HFO
011
027113
103CL4P
011-FE-0034
011-FT-0034-AA
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
3"
HFO
011
027113
103CL4P
Reducer
3"-HFO-011027113-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
1/2"
HFO
011
027113
103CL4P
011-FE-0034
011-FT-0034-AB
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
1/2"
HFO
011
027113
103CL4P
011-FE-0034
011-FT-0034-AB
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
4"
HFO
011
027113
103CL4P
Reducer
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
8"
HFO
011
027113
103CL4P
Reducer
8"-HFO-011027113-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
8"
HFO
011
027113
103CL4P
8"-HFO-011027113-103CL4P-S
SA-JER-DS011-TRJR-480071
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
8"
HFO
011
027113
103CL4P
Reducer
8"-HFO-011027113-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
6"
HFO
011
027113
103CL4P
6"-MPS-011028303-103CS1P-H
8"-HFO-011027113-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
3"
HFO
011
027113
103CL4P
3"-HFO-011027113-103CL4P-S
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480071
8"
HFO
011
027113
103CL4P
SA-JER-DS011-TRJR-480067
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid/Gas Mixture
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480071
1"
HFO
011
027113
103CL4P
011-PI-0101-A
8"-HFO-011027113-103CL4P-S
S
33.7
H
65
ATM. RESIDUE
Liquid/Gas Mixture
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480071
1"
HFO
011
027113
103CL4P
011-PT-0102-A
1"-HFO-011027113-103CL4P-S
S
33.7
H
65
ATM. RESIDUE
Liquid/Gas Mixture
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480071
6"
HFO
011
027113
103CL4P
Reducer
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid/Gas Mixture
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480071
5"
HFO
011
027113
103CL4P
Reducer
011-F-0002
S
33.7
H
100
ATM. RESIDUE
Liquid/Gas Mixture
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480066
8"
HFO
011
027114
101CL4P
8"-HFO-011027104-103CL4P-S
SA-JER-DS011-TRJR-480044
S
33.7
H
100
ATM. RESIDUE
Liquid
806
3.00
354.00
-
-
4.10
390.00
-
H
8.66
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480044
8"
HFO
011
027114
101CL4P
SA-JER-DS011-TRJR-480066
011-C-0002
S
33.7
H
100
ATM. RESIDUE
Liquid
806
3.00
354.00
-
-
4.10
390.00
-
H
8.66
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480312
6"
HFO
011
027115
103CL4P
12"-HFO-011027103-103CL4P-S
SA-JER-DS011-TRJR-480068
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
6"
HFO
011
027115
103CL4P
SA-JER-DS011-TRJR-480312
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
3"
HFO
011
027115
103CL4P
Reducer
3"-HFO-011027115-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
1/2"
HFO
011
027115
103CL4P
011-FE-0034
011-FT-0034-CB
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
1/2"
HFO
011
027115
103CL4P
011-FE-0034
011-FT-0034-CB
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
1/2"
HFO
011
027115
103CL4P
011-FE-0034
011-FT-0034-CA
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
1/2"
HFO
011
027115
103CL4P
011-FE-0034
011-FT-0034-CA
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
1/2"
HFO
011
027115
103CL4P
011-FE-0034
011-FT-0034-CC
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
6"
HFO
011
027115
103CL4P
6"-HFO-011027115-103CL4P-S
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
1/2"
HFO
011
027115
103CL4P
011-FE-0034
011-FT-0034-CC
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
4"
HFO
011
027115
103CL4P
Reducer
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
8"
HFO
011
027115
103CL4P
Reducer
8"-HFO-011027115-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
8"
HFO
011
027115
103CL4P
8"-HFO-011027115-103CL4P-S
SA-JER-DS011-TRJR-480073
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
8"
HFO
011
027115
103CL4P
Reducer
8"-HFO-011027115-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
3"
HFO
011
027115
103CL4P
3"-HFO-011027115-103CL4P-S
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
6"
HFO
011
027115
103CL4P
6"-MPS-011028306-103CS1P-H
8"-HFO-011027115-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480073
8"
HFO
011
027115
103CL4P
SA-JER-DS011-TRJR-480068
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480073
1"
HFO
011
027115
103CL4P
8"-HFO-011027115-103CL4P-S
011-PI-0101-C
S
33.7
H
65
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480073
1"
HFO
011
027115
103CL4P
1"-HFO-011027115-103CL4P-S
011-PT-0102-C
S
33.7
H
65
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480073
6"
HFO
011
027115
103CL4P
Reducer
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480073
5"
HFO
011
027115
103CL4P
Reducer
011-F-0002
S
33.7
H
100
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480312
6"
HFO
011
027116
103CL4P
12"-HFO-011027103-103CL4P-S
SA-JER-DS011-TRJR-480068
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
6"
HFO
011
027116
103CL4P
SA-JER-DS011-TRJR-480312
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
6"
HFO
011
027116
103CL4P
6"-HFO-011027116-103CL4P-S
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
1/2"
HFO
011
027116
103CL4P
011-FE-0034
011-FT-0034-DA
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
1/2"
HFO
011
027116
103CL4P
011-FE-0034
011-FT-0034-DC
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
1/2"
HFO
011
027116
103CL4P
011-FE-0034
011-FT-0034-DA
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
1/2"
HFO
011
027116
103CL4P
011-FE-0034
011-FT-0034-DB
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
3"
HFO
011
027116
103CL4P
Reducer
3"-HFO-011027116-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
1/2"
HFO
011
027116
103CL4P
011-FE-0034
011-FT-0034-DB
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
1/2"
HFO
011
027116
103CL4P
011-FE-0034
011-FT-0034-DC
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
4"
HFO
011
027116
103CL4P
Reducer
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
8"
HFO
011
027116
103CL4P
Reducer
8"-HFO-011027116-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
8"
HFO
011
027116
103CL4P
8"-HFO-011027116-103CL4P-S
SA-JER-DS011-TRJR-480074
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
6"
HFO
011
027116
103CL4P
6"-MPS-011028308-103CS1P-H
8"-HFO-011027116-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
8"
HFO
011
027116
103CL4P
Reducer
8"-HFO-011027116-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
3"
HFO
011
027116
103CL4P
3"-HFO-011027116-103CL4P-S
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480074
8"
HFO
011
027116
103CL4P
SA-JER-DS011-TRJR-480068
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480074
1"
HFO
011
027116
103CL4P
8"-HFO-011027116-103CL4P-S
011-PT-0102-D
S
33.7
H
65
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480074
1"
HFO
011
027116
103CL4P
8"-HFO-011027116-103CL4P-S
011-PI-0101-D
S
33.7
H
65
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480074
6"
HFO
011
027116
103CL4P
Reducer
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480074
5"
HFO
011
027116
103CL4P
Reducer
011-F-0002
S
33.7
H
100
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480312
6"
HFO
011
027117
103CL4P
12"-HFO-011027103-103CL4P-S
SA-JER-DS011-TRJR-480069
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
6"
HFO
011
027117
103CL4P
SA-JER-DS011-TRJR-480312
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
1/2"
HFO
011
027117
103CL4P
011-FE-0034
011-FT-0034-EB
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
1/2"
HFO
011
027117
103CL4P
011-FE-0034
011-FT-0034-EC
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
1/2"
HFO
011
027117
103CL4P
011-FE-0034
011-FT-0034-EC
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
3"
HFO
011
027117
103CL4P
Reducer
3"-HFO-011027117-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
1/2"
HFO
011
027117
103CL4P
011-FE-0034
011-FT-0034-EB
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
1/2"
HFO
011
027117
103CL4P
011-FE-0034
011-FT-0034-EA
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
6"
HFO
011
027117
103CL4P
6"-HFO-011027117-103CL4P-S
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
1/2"
HFO
011
027117
103CL4P
011-FE-0034
011-FT-0034-EA
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
4"
HFO
011
027117
103CL4P
Reducer
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
8"
HFO
011
027117
103CL4P
Reducer
8"-HFO-011027117-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
8"
HFO
011
027117
103CL4P
8"-HFO-011027117-103CL4P-S
SA-JER-DS011-TRJR-480075
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
3"
HFO
011
027117
103CL4P
3"-HFO-011027117-103CL4P-S
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
6"
HFO
011
027117
103CL4P
6"-MPS-011028310-103CS1P-H
8"-HFO-011027117-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
8"
HFO
011
027117
103CL4P
Reducer
8"-HFO-011027117-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
390.00
Page 89 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480075
8"
HFO
011
027117
103CL4P
SA-JER-DS011-TRJR-480069
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480075
1"
HFO
011
027117
103CL4P
011-PT-0102-E
1"-HFO-011027117-103CL4P-S
S
33.7
H
65
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480075
1"
HFO
011
027117
103CL4P
011-PI-0101-E
8"-HFO-011027117-103CL4P-S
S
33.7
H
65
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480075
6"
HFO
011
027117
103CL4P
Reducer
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480075
5"
HFO
011
027117
103CL4P
Reducer
011-F-0002
S
33.7
H
100
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480312
6"
HFO
011
027118
103CL4P
12"-HFO-011027103-103CL4P-S
SA-JER-DS011-TRJR-480069
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
6"
HFO
011
027118
103CL4P
SA-JER-DS011-TRJR-480312
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
1/2"
HFO
011
027118
103CL4P
011-FE-0034
011-FT-0034-FB
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
1/2"
HFO
011
027118
103CL4P
011-FE-0034
011-FT-0034-FA
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
1/2"
HFO
011
027118
103CL4P
011-FE-0034
011-FT-0034-FC
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
3"
HFO
011
027118
103CL4P
Reducer
3"-HFO-011027118-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
1/2"
HFO
011
027118
103CL4P
011-FE-0034
011-FT-0034-FC
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
1/2"
HFO
011
027118
103CL4P
011-FE-0034
011-FT-0034-FC
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
1/2"
HFO
011
027118
103CL4P
011-FE-0034
011-FT-0034-FA
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
6"
HFO
011
027118
103CL4P
6"-HFO-011027118-103CL4P-S
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
4"
HFO
011
027118
103CL4P
Reducer
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
8"
HFO
011
027118
103CL4P
Reducer
8"-HFO-011027118-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
8"
HFO
011
027118
103CL4P
8"-HFO-011027118-103CL4P-S
SA-JER-DS011-TRJR-480076
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
3"
HFO
011
027118
103CL4P
3"-HFO-011027118-103CL4P-S
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
6"
HFO
011
027118
103CL4P
6"-MPS-011028312-103CS1P-H
8"-HFO-011027118-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
8"
HFO
011
027118
103CL4P
Reducer
8"-HFO-011027118-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480076
8"
HFO
011
027118
103CL4P
SA-JER-DS011-TRJR-480069
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480076
1"
HFO
011
027118
103CL4P
011-PT-0102-F
8"-HFO-011027118-103CL4P-S
S
33.7
H
65
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480076
1"
HFO
011
027118
103CL4P
011-PI-0101-F
8"-HFO-011027118-103CL4P-S
S
33.7
H
65
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480076
6"
HFO
011
027118
103CL4P
Reducer
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480076
5"
HFO
011
027118
103CL4P
Reducer
011-F-0002
S
33.7
H
100
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480312
6"
HFO
011
027119
103CL4P
12"-HFO-011027103-103CL4P-S
SA-JER-DS011-TRJR-480070
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480077
5"
HFO
011
027119
103CL4P
Reducer
011-F-0002
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480077
6"
HFO
011
027119
103CL4P
011-F-0002
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
390.00
SA-JER-DS011-TRJR-480070
6"
HFO
011
027119
103CL4P
SA-JER-DS011-TRJR-480312
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
1/2"
HFO
011
027119
103CL4P
011-FE-0034
011-FT-0034-GC
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
6"
HFO
011
027119
103CL4P
6"-HFO-011027119-103CL4P-S
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
1/2"
HFO
011
027119
103CL4P
011-FE-0034
011-FT-0034-GA
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
3"
HFO
011
027119
103CL4P
Reducer
3"-HFO-011027119-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
1/2"
HFO
011
027119
103CL4P
011-FE-0034
011-FT-0034-GB
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
1/2"
HFO
011
027119
103CL4P
011-FE-0034
011-FT-0034-GC
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
1/2"
HFO
011
027119
103CL4P
011-FE-0034
011-FT-0034-GC
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
1/2"
HFO
011
027119
103CL4P
011-FE-0034
011-FT-0034-GA
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
4"
HFO
011
027119
103CL4P
Reducer
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
8"
HFO
011
027119
103CL4P
Reducer
8"-HFO-011027119-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
8"
HFO
011
027119
103CL4P
8"-HFO-011027119-103CL4P-S
SA-JER-DS011-TRJR-480077
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
6"
HFO
011
027119
103CL4P
6"-MPS-011028314-103CS1P-H
8"-HFO-011027119-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
3"
HFO
011
027119
103CL4P
3"-HFO-011027119-103CL4P-S
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
8"
HFO
011
027119
103CL4P
Reducer
8"-HFO-011027119-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480077
8"
HFO
011
027119
103CL4P
SA-JER-DS011-TRJR-480070
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480077
1"
HFO
011
027119
103CL4P
1"-HFO-011027119-103CL4P-S
011-PT-0102-G
S
33.7
H
65
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480077
1"
HFO
011
027119
103CL4P
8"-HFO-011027119-103CL4P-S
011-PI-0101-G
S
33.7
H
65
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480077
6"
HFO
011
027119
103CL4P
Reducer
011-F-0002
S
33.7
H
100
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480312
6"
HFO
011
027120
103CL4P
12"-HFO-011027103-103CL4P-S
SA-JER-DS011-TRJR-480070
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
6"
HFO
011
027120
103CL4P
SA-JER-DS011-TRJR-480312
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
1/2"
HFO
011
027120
103CL4P
011-FE-0034
011-FT-0034-HB
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
1/2"
HFO
011
027120
103CL4P
011-FE-0034
011-FT-0034-HC
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
1/2"
HFO
011
027120
103CL4P
011-FE-0034
011-FT-0034-HA
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
3"
HFO
011
027120
103CL4P
Reducer
3"-HFO-011027120-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
1/2"
HFO
011
027120
103CL4P
011-FE-0034
011-FT-0034-HC
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
1/2"
HFO
011
027120
103CL4P
011-FE-0034
011-FT-0034-HB
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
6"
HFO
011
027120
103CL4P
6"-HFO-011027120-103CL4P-S
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
1/2"
HFO
011
027120
103CL4P
011-FE-0034
011-FT-0034-HA
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
4"
HFO
011
027120
103CL4P
Reducer
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
8"
HFO
011
027120
103CL4P
Reducer
8"-HFO-011027120-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
8"
HFO
011
027120
103CL4P
8"-HFO-011027120-103CL4P-S
SA-JER-DS011-TRJR-480078
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
3"
HFO
011
027120
103CL4P
3"-HFO-011027120-103CL4P-S
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
8"
HFO
011
027120
103CL4P
Reducer
8"-HFO-011027120-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
6"
HFO
011
027120
103CL4P
6"-MPS-011028316-103CS1P-H
8"-HFO-011027120-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480078
8"
HFO
011
027120
103CL4P
SA-JER-DS011-TRJR-480070
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480078
1"
HFO
011
027120
103CL4P
8"-HFO-011027120-103CL4P-S
011-PI-0101-H
S
33.7
H
65
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480078
1"
HFO
011
027120
103CL4P
8"-HFO-011027120-103CL4P-S
011-PT-0102-H
S
33.7
H
65
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480078
6"
HFO
011
027120
103CL4P
Reducer
Reducer
-
33.7
H
100
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480078
5"
HFO
011
027120
103CL4P
Reducer
011-F-0002
S
33.7
H
100
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
4"
HFO
011
027121
103CL4P
18"-HFO-011018101-103CL4P-S
4"-CLD-011027306-101CH2S-P
S
33.7
H
100
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027121
103CL4P
4"-HFO-011027121-103CL4P-S
Blind flange
S
33.7
H
65
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
4"
HFO
011
027122
103CL4P
18"-HFO-011018101-103CL4P-S
4"-CLD-011027306-101CH2S-P
S
33.7
H
100
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027122
103CL4P
4"-HFO-011027122-103CL4P-S
Blind flange
S
33.7
H
65
ATM. RESIDUE
Liquid
807
1.60
354.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027123
103CL4P
12"-HFO-011027105-103CL4P-S
Reducer
S
33.7
H
65
ATM. RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027123
103CL4P
1"-HFO-011027123-103CL4P-S
Blind flange
S
33.7
H
65
ATM. RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
2"
HFO
011
027123
103CL4P
Reducer
2"-CLD-011027308-101CH2S-P
S
33.7
H
75
ATM. RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480066
1"
HFO
011
027124
103CL4P
6"-HFO-011039104-103CL4P-S
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TARCING WITH MPS.
SA-JER-DS011-TRJR-480066
1"
HFO
011
027124
103CL4P
1"-HFO-011027124-103CL4P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TARCING WITH MPS.
SA-JER-DS011-TRJR-480066
2"
HFO
011
027124
103CL4P
Reducer
2"-CLD-011027309-101CH2S-P
S
155
H
75
VACUUM RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480066
1"
HFO
011
027132
103CL4P
10"-HFO-011039104-103CL4P-S
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS
SA-JER-DS011-TRJR-480066
1"
HFO
011
027132
103CL4P
1"-HFO-011027132-103CL4P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS
SA-JER-DS011-TRJR-480066
2"
HFO
011
027132
103CL4P
Reducer
2"-CLD-011027310-101CH2S-P
S
155
H
75
VACUUM RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS
SA-JER-DS011-TRJR-480067
1"
HFO
011
028101
103CL4P
6"-HFO-011027113-103CL4P-S
Reducer
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
1"
HFO
011
028101
103CL4P
1"-HFO-011028101-103CL4P-S
Blind flange
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
2"
HFO
011
028101
103CL4P
Reducer
2"-CLD-011028301-101CH2S-P
S
33.7
H
75
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
1"
HFO
011
028102
103CL4P
6"-HFO-011027103-103CL4P-S
Reducer
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
1"
HFO
011
028102
103CL4P
1"-HFO-011028102-103CL4P-S
Blind flange
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
2"
HFO
011
028102
103CL4P
Reducer
2"-CLD-011028302-101CH2S-P
S
33.7
H
75
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
1"
HFO
011
028103
103CL4P
6"-HFO-011027115-103CL4P-S
Reducer
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
1"
HFO
011
028103
103CL4P
1"-HFO-011028103-103CL4P-S
Blind flange
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
2"
HFO
011
028103
103CL4P
Reducer
2"-CLD-011028303-101CH2S-P
S
33.7
H
75
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 90 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
INSULATION (NOTE 2)
TYPE
FLUID
THICKNESS (mm)
PHASE
(NOTE 3)
DOC. No.
DENSITY (kg/m3)
(NOTE 4)
OPERATING CONDITIONS PRESS. (BARG)
TEMP. (ºC)
DESIGN CONDITIONS
ALTERNATE CONDITIONS PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
(ºC)
TEST CONDITIONS
MEDIUM (NOTE 5)
PRESS. (BARG)
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6)
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480068
1"
HFO
011
028104
103CL4P
6"-HFO-011027116-103CL4P-S
Reducer
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
1"
HFO
011
028104
103CL4P
1"-HFO-011028104-103CL4P-S
Blind flange
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480068
2"
HFO
011
028104
103CL4P
Reducer
2"-CLD-011028304-101CH2S-P
S
33.7
H
75
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
1"
HFO
011
028105
103CL4P
6"-HFO-011027117-103CL4P-S
Reducer
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
1"
HFO
011
028105
103CL4P
1"-HFO-011028105-103CL4P-S
Blind flange
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
2"
HFO
011
028105
103CL4P
Reducer
2"-CLD-011028305-101CH2S-P
S
33.7
H
75
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
1"
HFO
011
028106
103CL4P
6"-HFO-011027118-103CL4P-S
Reducer
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
1"
HFO
011
028106
103CL4P
1"-HFO-011028106-103CL4P-S
Blind flange
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480069
2"
HFO
011
028106
103CL4P
Reducer
2"-CLD-011028306-101CH2S-P
S
33.7
H
75
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
1"
HFO
011
028107
103CL4P
6"-HFO-011027119-103CL4P-S
Reducer
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
1"
HFO
011
028107
103CL4P
1"-HFO-011028107-103CL4P-S
Blind flange
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
2"
HFO
011
028107
103CL4P
Reducer
2"-CLD-011028307-101CH2S-P
S
33.7
H
75
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
1"
HFO
011
028108
103CL4P
6"-HFO-011027120-103CL4P-S
Reducer
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
1"
HFO
011
028108
103CL4P
1"-HFO-011028108-103CL4P-S
Blind flange
S
33.7
H
65
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480070
2"
HFO
011
028108
103CL4P
Reducer
2"-CLD-011028308-101CH2S-P
S
33.7
H
75
ATM. RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
8"
HFO
011
028109
103CL4P
8"-HFO-011027103-103CL4P-S
SA-JER-DS011-TRJR-480072
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
3"
HFO
011
028109
103CL4P
3"-HFO-011027103-103CL4P-S
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
6"
HFO
011
028109
103CL4P
10"-MPS-011028301-103CS1P-H
8"-HFO-011028109-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480067
8"
HFO
011
028109
103CL4P
Reducer
8"-HFO-011028109-103CL4P-S
S
33.7
H
100
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480072
1"
HFO
011
028109
103CL4P
8"-HFO-011028109-103CL4P-S
011-PT-0102-B
S
33.7
H
65
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480072
1"
HFO
011
028109
103CL4P
8"-HFO-011028109-103CL4P-S
011-PI-0101-B
S
33.7
H
65
ATM. RESIDUE
Liquid
806
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480072
8"
HFO
011
028109
103CL4P
SA-JER-DS011-TRJR-480067
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
390.00
Reducer
Reducer
S
33.7
H
100
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480072
5"
HFO
011
028109
103CL4P
Reducer
011-F-0002
S
33.7
H
100
ATM. RESIDUE
Liquid
811.2
8.40
354.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480078
12"
HFO
011
029101
101CM2P
011-F-0002
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480078
14"
HFO
011
029101
101CM2P
Reducer
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480081
64"
HFO
011
029101
101CM2P
SA-JER-DS011-TRJR-480078
011-C-0003
-
-
H
150
ATM. RESIDUE
Liquid/Gas Mixture
5
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480081
2"
HFO
011
029101
101CM2P 64"-HFO-011029101-101CM2P-H
011-TT-0142
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
5
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480078
16"
HFO
011
029101
101CM2P
Reducer
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480078
20"
HFO
011
029101
101CM2P
Reducer
64"-HFO-011029101-101CM2P-H
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480078
2"
HFO
011
029101
101CM2P 20"-HFO-011029101-101CM2P-H
Flange
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480078
2"
HFO
011
029101
101CM2P 20"-HFO-011029101-101CM2P-H
Flange
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480078
64"
HFO
011
029101
101CM2P
HEADER
SA-JER-DS011-TRJR-480081
-
-
H
150
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480077
16"
HFO
011
029101
101CM2P
Reducer
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480078
20"
HFO
011
029101
101CM2P
SA-JER-DS011-TRJR-480076
64"-HFO-011029101-101CM2P-H
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480078
20"
HFO
011
029101
101CM2P
SA-JER-DS011-TRJR-480072
64"-HFO-011029101-101CM2P-H
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480075
16"
HFO
011
029101
101CM2P
Reducer
SA-JER-DS011-TRJR-480075
2"
HFO
011
029101
101CM2P 16"-HFO-011029101-101CM2P-H
SA-JER-DS011-TRJR-480076
16"
HFO
011
029101
101CM2P
SA-JER-DS011-TRJR-480077
14"
HFO
011
029101
SA-JER-DS011-TRJR-480075
14"
HFO
011
SA-JER-DS011-TRJR-480076
2"
HFO
SA-JER-DS011-TRJR-480072
12"
SA-JER-DS011-TRJR-480076 SA-JER-DS011-TRJR-480072
SA-JER-DS011-TRJR-480072
6"
HFO
011
028109
103CL4P
-1.00
440.00
440.00
-
NOTE 6.
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
011-TT-0148-E
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
Reducer
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
101CM2P
Reducer
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
029101
101CM2P
Reducer
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
011
029101
101CM2P 20"-HFO-011029101-101CM2P-H
Flange
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
HFO
011
029101
101CM2P
011-F-0002
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
14"
HFO
011
029101
101CM2P
Reducer
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
16"
HFO
011
029101
101CM2P
Reducer
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480073
2"
HFO
011
029101
101CM2P 20"-HFO-011029101-101CM2P-H
011-TT-0148-C
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480075
20"
HFO
011
029101
101CM2P
Reducer
SA-JER-DS011-TRJR-480078
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480078
20"
HFO
011
029101
101CM2P
SA-JER-DS011-TRJR-480071
64"-HFO-011029101-101CM2P-H
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480072
20"
HFO
011
029101
101CM2P
Reducer
SA-JER-DS011-TRJR-480078
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480072
2"
HFO
011
029101
101CM2P 20"-HFO-011029101-101CM2P-H
011-TT-0148-B
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480078
20"
HFO
011
029101
101CM2P
64"-HFO-011029101-101CM2P-H
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480077
2"
HFO
011
029101
101CM2P 20"-HFO-011029101-101CM2P-H
011-TT-0148-G
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480075
2"
HFO
011
029101
101CM2P 20"-HFO-011029101-101CM2P-H
011-TT-0140-E
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480077
2"
HFO
011
029101
101CM2P 20"-HFO-011029101-101CM2P-H
011-TT-0140-G
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480073
16"
HFO
011
029101
101CM2P
Reducer
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480078
20"
HFO
011
029101
101CM2P
SA-JER-DS011-TRJR-480073
64"-HFO-011029101-101CM2P-H
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480076
20"
HFO
011
029101
101CM2P
Reducer
SA-JER-DS011-TRJR-480078
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480071
20"
HFO
011
029101
101CM2P
Reducer
SA-JER-DS011-TRJR-480078
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480072
14"
HFO
011
029101
101CM2P
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480074
2"
HFO
011
029101
101CM2P 20"-HFO-011029101-101CM2P-H
011-TT-0140-D
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480073
12"
HFO
011
029101
101CM2P
011-F-0002
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480073
20"
HFO
011
029101
101CM2P
Reducer
SA-JER-DS011-TRJR-480078
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480071
16"
HFO
011
029101
101CM2P
Reducer
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480074
20"
HFO
011
029101
101CM2P
Reducer
SA-JER-DS011-TRJR-480078
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480075
12"
HFO
011
029101
101CM2P
011-F-0002
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480078
20"
HFO
011
029101
101CM2P
SA-JER-DS011-TRJR-480074
64"-HFO-011029101-101CM2P-H
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480074
14"
HFO
011
029101
101CM2P
Reducer
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480074
12"
HFO
011
029101
101CM2P
011-F-0002
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480071
14"
HFO
011
029101
101CM2P
Reducer
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480074
2"
HFO
011
029101
101CM2P 20"-HFO-011029101-101CM2P-H
011-TT-0148-D
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480076
12"
HFO
011
029101
101CM2P
011-F-0002
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480077
20"
HFO
011
029101
101CM2P
Reducer
SA-JER-DS011-TRJR-480078
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480071
12"
HFO
011
029101
101CM2P
011-F-0002
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480074
16"
HFO
011
029101
101CM2P
Reducer
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480077
12"
HFO
011
029101
101CM2P
011-F-0002
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480073
2"
HFO
011
029101
101CM2P 20"-HFO-011029101-101CM2P-H
011-TT-0140-C
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480073
14"
HFO
011
029101
101CM2P
Reducer
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480072
2"
HFO
011
029101
101CM2P 20"-HFO-011029101-101CM2P-H
011-TT-0140-B
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480078
20"
HFO
011
029101
101CM2P
64"-HFO-011029101-101CM2P-H
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480076
2"
HFO
011
029101
101CM2P 20"-HFO-011029101-101CM2P-H
Flange
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
4.8
-0.61
407.00
-
-
3.50
-1.00
440.00
440.00
-
H
8.42
NFS
YES
O or Q
N
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480072
5"
HFO
011
029102
103CM4P
011-F-0002
011-F-0002
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
799
5.70
370.00
-
-
12.00
-1.00
410.00
-
H
27.60
NFS YES
N or Q
N
N
N
N
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480073
5"
HFO
011
029103
103CM4P
011-F-0002
011-F-0002
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
799
5.70
370.00
-
-
12.00
-1.00
410.00
-
H
27.60
NFS YES
N or Q
N
N
N
N
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480073
2"
HFO
011
029103
103CM4P
5"-HFO-011029103-103CM4P-H
011-TE-0135-C
-
-
H
75
ATM. RESIDUE
Liquid/Gas Mixture
799
5.70
370.00
-
-
12.00
-1.00
410.00
-
H
27.60
NFS YES
N or Q
N
N
N
N
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480074
5"
HFO
011
029104
103CM4P
011-F-0002
011-F-0002
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
799
5.70
370.00
-
-
12.00
-1.00
410.00
-
H
27.60
NFS YES
N or Q
N
N
N
N
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480075
5"
HFO
011
029105
103CM4P
011-F-0002
011-F-0002
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
799
5.70
370.00
-
-
12.00
-1.00
410.00
-
H
27.60
YES NFS
N or Q
N
N
N
N
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480076
5"
HFO
011
029106
103CM4P
011-F-0002
011-F-0002
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
799
5.70
370.00
-
-
12.00
-1.00
410.00
-
H
27.60
NFS YES
N or Q
N
N
N
N
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480077
5"
HFO
011
029107
103CM4P
011-F-0002
011-F-0002
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
799
5.70
370.00
-
-
12.00
-1.00
410.00
-
H
27.60
NFS YES
N or Q
N
N
N
N
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480078
5"
HFO
011
029108
103CM4P
011-F-0002
011-F-0002
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
799
5.70
370.00
-
-
12.00
-1.00
410.00
-
H
27.60
NFS YES
N or Q
N
N
N
N
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480071
1-1/2"
HFO
011
029118
103CM4P
3"-MPS-011029001-103CM4P-H
Insul Brk
-
-
H
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS YES
N or Q
N
POTENTIAL
N
N
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480071
1-1/2"
HFO
011
029118
103CM4P
Insul Brk
Reducer
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480071
1"
HFO
011
029118
103CM4P
1-1/2"-HFO-011029118-103CM4PP
Blind flange
-
-
P
50
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
SA-JER-DS011-TRJR-480077
Reducer
Reducer
SA-JER-DS011-TRJR-480075
Page 91 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
INSULATION (NOTE 2)
TYPE
FLUID
THICKNESS (mm)
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480071
2"
HFO
011
029118
103CM4P
Reducer
2"-CLD-011029301-101CH2S-P
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480072
1-1/2"
HFO
011
029119
103CM4P
3"-MPS-011029002-103CM4P-H
Insul Brk
-
-
H
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS YES
N or Q
N
POTENTIAL
N
N
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480072
1-1/2"
HFO
011
029119
103CM4P
Insul Brk
Reducer
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480072
1"
HFO
011
029119
103CM4P
1-1/2"-HFO-011029119-103CM4PP
Blind flange
-
-
P
50
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480072
2"
HFO
011
029119
103CM4P
Reducer
2"-CLD-011029302-101CH2S-P
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480073
1-1/2"
HFO
011
029120
103CM4P
Insul Brk
Reducer
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480073
1-1/2"
HFO
011
029120
103CM4P
3"-MPS-011029003-103CM4P-H
Insul Brk
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480073
1"
HFO
011
029120
103CM4P
1-1/2"-HFO-011029120-103CM4PP
Blind flange
-
-
P
50
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480073
2"
HFO
011
029120
103CM4P
Reducer
2"-CLD-011029303-101CH2S-P
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480074
1-1/2"
HFO
011
029121
103CM4P
Insul Brk
Reducer
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480074
1-1/2"
HFO
011
029121
103CM4P
3"-MPS-011029004-103CM4P-H
Insul Brk
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480074
1"
HFO
011
029121
103CM4P
1-1/2"-HFO-011029121-103CM4PP
Blind flange
-
-
P
50
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480074
2"
HFO
011
029121
103CM4P
Reducer
2"-CLD-011029304-101CH2S-P
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480075
1-1/2"
HFO
011
029122
103CM4P
Insul Brk
Reducer
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480075
1-1/2"
HFO
011
029122
103CM4P
3"-MPS-011029005-103CM4P-H
Insul Brk
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480075
1"
HFO
011
029122
103CM4P
1-1/2"-HFO-011029122-103CM4PP
Blind flange
-
-
P
50
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480075
2"
HFO
011
029122
103CM4P
Reducer
2"-CLD-011029305-101CH2S-P
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480076
1-1/2"
HFO
011
029123
103CM4P
Insul Brk
Reducer
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480076
1-1/2"
HFO
011
029123
103CM4P
3"-MPS-011029006-103CM4P-H
Insul Brk
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480076
1"
HFO
011
029123
103CM4P
1-1/2"-HFO-011029123-103CM4PP
Blind flange
-
-
P
50
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480076
2"
HFO
011
029123
103CM4P
Reducer
2"-CLD-011029306-101CH2S-P
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480077
1-1/2"
HFO
011
029124
103CM4P
Insul Brk
Reducer
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480077
1"
HFO
011
029124
103CM4P
1-1/2"-HFO-011029124-103CM4PP
Blind flange
-
-
P
50
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480077
1-1/2"
HFO
011
029124
103CM4P
3"-MPS-011029007-103CM4P-H
Insul Brk
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1.00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480077
2"
HFO
011
029124
103CM4P
Reducer
2"-CLD-011029307-101CH2S-P
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480078
1-1/2"
HFO
011
029125
103CM4P
Insul Brk
Reducer
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480078
1"
HFO
011
029125
103CM4P
1-1/2"-HFO-011029125-103CM4PP
Blind flange
-
-
P
50
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480078
1-1/2"
HFO
011
029125
103CM4P
3"-MPS-011029008-103CM4P-H
Insul Brk
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480078
2"
HFO
011
029125
103CM4P
Reducer
2"-CLD-011029308-101CH2S-P
-
-
P
65
ATM. RESIDUE
Liquid/Gas Mixture
-
5.00
368.00
-
-
12.00
-1,00
440.00
440.00
-
H
28.87
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480071
5"
HFO
011
029126
103CM4P
011-F-0002
011-F-0002
-
-
H
100
ATM. RESIDUE
Liquid/Gas Mixture
799
5.70
370.00
-
-
12.00
-1.00
410.00
-
H
27.60
NFS YES
N or Q
N
POTENTIAL
N
N
N
N
By Vendor
NOTE 6
SA-JER-DS011-TRJR-480081
24"
HFO
011
030001
101CL2P
011-C-0003
Reducer
S
31
H
100
HVGO
Liquid
775
1.31
322.00
-
-
6.10
-1.00
400.00
-
H
13.88
NFS
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480081
24"
HFO
011
030001
101CL2P
011-C-0003
Reducer
S
31
H
100
HVGO
Liquid
775
1.31
322.00
-
-
6.10
-1.00
400.00
400.00
-
H
13.88
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480081
28"
HFO
011
030001
101CL2P
Reducer
SA-JER-DS011-TRJR-480101
S
31
H
100
HVGO
Liquid
775
1.31
322.00
-
-
6.10
-1.00
400.00
400.00
-
H
13.88
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480081
2"
HFO
011
030001
101CL2P
28"-HFO-011030001-101CL2P-S
011-TT-0201
S
31
H
65
HVGO
Liquid
775
1.31
322.00
-
-
6.10
-1.00
400.00
400.00
-
H
13.88
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480081
28"
HFO
011
030001
101CL2P
Reducer
28"-HFO-011030001-101CL2P-S
S
31
H
100
HVGO
Liquid
775
1.31
322.00
-
-
6.10
-1.00
400.00
400.00
-
H
13.88
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
28"
HFO
011
030001
101CL2P
SA-JER-DS011-TRJR-480081
Reducer
S
31
H
100
HVGO
Liquid
775
1.31
322.00
-
-
6.10
-1.00
400.00
400.00
-
H
13.88
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
4"
HFO
011
030001
101CL2P
4"-FLO-011039301-101CS1P-N
4"-HFO-011030001-101CL2P-S
S
31
H
100
HVGO
Liquid
775
1.31
322.00
-
-
6.10
-1.00
400.00
400.00
-
H
13.88
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
3/4"
HFO
011
030001
101CL2P
4"-HFO-011030001-101CL2P-S
Plug
S
31
H
65
HVGO
Liquid
775
1.31
322.00
-
-
6.10
-1.00
400.00
400.00
-
H
13.88
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
4"-HFO-011030001-101CL2P-S
28"-HFO-011030001-101CL2P-S
S
31
H
100
HVGO
Liquid
775
1.31
322.00
-
-
6.10
-1.00
400.00
400.00
-
H
13.88
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
31
H
100
775
1.31
322.00
-
-
6.10
-1.00
400.00
400.00
-
H
13.88
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
400.00
YES
YES
SA-JER-DS011-TRJR-480101
4"
HFO
011
030001
101CL2P
SA-JER-DS011-TRJR-480101
20"
HFO
011
030001
101CL2P
Reducer
20"-HFO-011039001-103CL2P-S
S
HVGO
Liquid
SA-JER-DS011-TRJR-480101
28"
HFO
011
030001
101CL2P
28"-HFO-011030001-101CL2P-S
Reducer
S
31
H
100
HVGO
Liquid
775
1.31
322.00
-
-
6.10
-1.00
400.00
400.00
-
H
13.88
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
20"
HFO
011
030001
101CL2P
Reducer
20"-HFO-011039002-103CL2P-S
S
31
H
100
HVGO
Liquid
775
1.31
322.00
-
-
6.10
-1.00
400.00
400.00
-
H
13.88
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
8"
HFO
011
030002
101CL2P
011-C-0003
SA-JER-DS011-TRJR-480099
S
22
H
100
MVGO
Liquid
775
1.90
267.00
-
-
6.68
-1.00
300.00
300.00
-
H
11.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
2"
HFO
011
030002
101CL2P
8"-HFO-011030002-101CL2P-S
011-TT-0200
S
22
H
65
MVGO
Liquid
775
1.90
267.00
-
-
6.68
-1.00
300.00
300.00
-
H
11.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
8"
HFO
011
030002
101CL2P
SA-JER-DS011-TRJR-480080
8"-HFO-011038001-103CL2P-S
S
22
H
100
MVGO
Liquid
775
1.90
267.00
-
-
6.68
-1.00
300.00
300.00
-
H
11.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
8"
HFO
011
030002
101CL2P
8"-HFO-011030002-101CL2P-S
8"-HFO-011038002-103CL2P-S
S
22
H
100
MVGO
Liquid
775
1.90
267.00
-
170.00
6.68
-1.00
300.00
300.00
-
H
11.87
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
3/4"
HFO
011
030004
101CL2P
011-LG-0045
Reducer
S
22
H
65
MVGO
Liquid
775
1.90
267.00
-
-
3.50
-1.00
370.00
370.00
-
H
6.44
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
3/4"
HFO
011
030004
101CL2P
3/4"-HFO-011030004-101CL2P-S
Plug
S
22
H
65
MVGO
Liquid
775
1.90
267.00
-
-
3.50
-1.00
370.00
370.00
-
H
6.44
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
2"
HFO
011
030004
101CL2P
Reducer
2"-CLD-011030302-101CH2S-P
S
22
H
65
MVGO
Liquid
775
1.90
267.00
-
-
3.50
-1.00
370.00
370.00
-
H
6.44
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480081
3/4"
HFO
011
030009
101SD0P
011-LG-0047
3/4"-LFL-011030302-101CH2F-N
S
31
H
65
HVGO
Gas
-
-0.83
322.00
-
-
3.50
-1.00
430.00
430.00
-
H
6.61
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480081
3/4"
HFO
011
030009
101SD0P 3/4"-HFO-011030009-101SD0P-S
Plug
S
31
H
65
HVGO
Gas
-
-0.83
322.00
-
-
3.50
-1.00
430.00
430.00
-
H
6.61
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
3/4"
HFO
011
030010
101CL2P
011-LG-0045
3/4"-LFL-011030305-101CH2F-N
-
-
P
40
MVGO
Gas
-
-0.83
267.00
-
-
3.50
-1.00
370.00
370.00
-
H
6.44
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480080
3/4"
HFO
011
030010
101CL2P
3/4"-HFO-011030010-101CL2P-P
Plug
-
-
P
40
MVGO
Gas
-
-0.83
267.00
-
-
3.50
-1.00
370.00
370.00
-
H
6.44
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
if insulated N or Q SA-JER-DS011-TRJR-480081
-
HFO
011
030101
103CL4P
011-C-0003
TRIM
S
155
H
-
-
-
-
-0.83
360.00
-
-
3.50
-1.00
430.00
430.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480081
2"
HFO
011
030101
103CL4P
011-C-0003
011-LT-0126
S
155
H
75
-
-
-
-0.83
360.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
SA-JER-DS011-TRJR-480081
2"
HFO
011
030101
103CL4P
011-C-0003
011-LG-0049-A
S
155
H
75
-
-
-
-0.83
360.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
SA-JER-DS011-TRJR-480081
2"
HFO
011
030101
103CL4P
011-C-0003
011-LG-0049-B
S
155
H
75
-
-
-
-0.83
360.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
SA-JER-DS011-TRJR-480081
2"
HFO
011
030101
103CL4P
011-C-0003
011-LT-0127
S
155
H
75
-
-
-
-0.83
360.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
SA-JER-DS011-TRJR-480081
2"
HFO
011
030101
103CL4P
011-C-0003
011-LT-0126
S
155
H
75
-
-
-
-0.83
360.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
SA-JER-DS011-TRJR-480081
2"
HFO
011
030101
103CL4P
011-C-0003
011-LG-0049-B
S
155
H
75
-
-
-
-0.83
360.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
SA-JER-DS011-TRJR-480081
2"
HFO
011
030101
103CL4P
011-C-0003
011-LG-0049-A
S
155
H
75
-
-
-
-0.83
360.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
SA-JER-DS011-TRJR-480081
18"
HFO
011
030101
103CL4P
011-ZV-0016
SA-JER-DS011-TRJR-480103
S
155
H
100
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
18"
HFO
011
030101
103CL4P
SA-JER-DS011-TRJR-480081
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
2"
HFO
011
030101
103CL4P
18"-HFO-011030101-103CL4P-S
011-TT-0204
S
155
H
75
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
2"
HFO
011
030101
103CL4P
18"-HFO-011030101-103CL4P-S
011-TT-0203
S
155
H
75
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
1"
HFO
011
030101
103CL4P
4"-HFO-011030101-103CL4P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
4"
HFO
011
030101
103CL4P
4"-FLO-011039306-101CS1P-N
18"-HFO-011030101-103CL4P-S
S
155
H
100
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-380001
if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q
Page 92 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
FLUID
THICKNESS (mm)
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480103
2"
HFO
011
030101
103CL4P
18"-HFO-011030101-103CL4P-S
Blind flange
S
155
H
75
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
16"
HFO
011
030101
103CL4P
Reducer
16"-HFO-011039101-103CL4P-S
S
155
H
100
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
18"
HFO
011
030101
103CL4P
18"-HFO-011030101-103CL4P-S
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
16"
HFO
011
030101
103CL4P
Reducer
16"-HFO-011039102-103CL4P-S
S
155
H
100
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
6"
HFO
011
030102
101CL4P
011-C-0003
6"-OLW-011030301-101CS1P-N
S
155
H
100
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
4.60
-1.00
430.00
430.00
-
H
10.85
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
2"
HFO
011
030102
103CM4P
011-C-0003
011-PT-0306
S
155
H
75
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
2"
HFO
011
030102
103CM4P
011-C-0003
011-PI-0073
S
155
H
75
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
2"
HFO
011
030102
103CM4P
011-C-0003
011-PDT-0103
S
155
H
75
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
2"
HFO
011
030102
103CM4P
011-C-0003
011-PT-0072
S
155
H
75
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
2"
HFO
011
030102
103CM4P
011-C-0003
011-PDT-0103
S
155
H
75
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
-
HFO
011
030102
103CM4P
011-C-0003
TRIM
-
-
H
100
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
3.50
-1.00
430.00
430.00
-
Visual Test
0.00
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
2"
HFO
011
030102
103CM4P
011-C-0003
011-PT-0070
S
155
H
75
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
4"
HFO
011
030103
101CL4P
18"-HFO-011030111-101CL4P-S
4"-CLD-011030304-101CH2S-P
S
155
H
100
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
4.60
-1.00
430.00
430.00
-
H
10.85
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
-
HFO
011
030103
101CL4P
011-C-0003
TRIM
-
-
H
100
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
3.50
-1.00
430.00
430.00
-
Visual Test
0.00
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
3/4"
HFO
011
030103
101CL4P
4"-HFO-011030103-101CL4P-S
1"-OLW-011030302-101CS1P-N
S
155
H
65
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
4.60
-1.00
430.00
430.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
3/4"
HFO
011
030103
101CL4P
011-LG-0049-B
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
4.60
-1.00
430.00
430.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
1"
HFO
011
030103
101CL4P
Reducer
4"-HFO-011030103-101CL4P-S
S
155
H
65
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
4.60
-1.00
430.00
430.00
-
H
10.85
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
3/4"
HFO
011
030103
101CL4P
011-LG-0049-A
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
4.60
-1.00
430.00
430.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
1"
HFO
011
030103
101CL4P
Reducer
1"-HFO-011030103-101CL4P-S
S
155
H
65
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
4.60
-1.00
430.00
430.00
-
H
10.85
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
3/4"
HFO
011
030107
101SD0P
011-LG-0047
Reducer
S
31
H
65
HVGO
Liquid
775
0.90
322.00
-
-
3.50
-1.00
430.00
430.00
-
H
6.61
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480081
3/4"
HFO
011
030107
101SD0P 3/4"-HFO-011030107-101SD0P-S
3/4"-OLW-011030303-101CS1PN
S
31
H
65
HVGO
Liquid
775
0.90
322.00
-
-
3.50
-1.00
430.00
430.00
-
H
6.61
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480081
2"
HFO
011
030107
101SD0P
Reducer
2"-CLD-011030303-101CH2S-P
S
31
H
65
HVGO
Liquid
775
0.90
322.00
-
-
3.50
-1.00
430.00
430.00
-
H
6.61
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480081
1"
HFO
011
030108
101CM2P
8"-RES-011030009-101CM2P-S
Reducer
S
155
H
65
ATM. RESIDUE
Liquid
845
-0.90
396.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
3/4"
HFO
011
030108
101CM2P
1"-HFO-011030108-101CM2P-S
3/4"-OLW-011030305-101CS1PN
S
155
H
65
ATM. RESIDUE
Liquid
845
-0.90
396.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
2"
HFO
011
030108
101CM2P
Reducer
2"-CLD-011030307-101CH2S-P
S
155
H
75
ATM. RESIDUE
Liquid
845
-0.90
396.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
2"
HFO
011
030109
101CM2P
2"-FLO-011030301-101CS1P-N
8"-HFO-011030109-101CM2P-S
S
155
H
75
VACUUM RESIDUE
Liquid
845
-0.90
396.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
3/4"
HFO
011
030109
101CM2P
2"-HFO-011030109-101CM2P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
845
-0.90
396.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
8"
HFO
011
030109
101CM2P
011-C-0003
8"-RES-011030009-101CM2P-S
S
155
H
100
ATM. RESIDUE
Liquid
845
-0.90
396.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
2"
HFO
011
030109
101CM2P
8"-HFO-011030109-101CM2P-S
011-TT-0328
S
155
H
75
ATM. RESIDUE
Liquid
845
-0.90
396.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
8"
HFO
011
030109
101CM2P
8"-RES-011030009-101CM2P-S
011-C-0003
S
155
H
100
ATM. RESIDUE
Liquid
845
-0.90
396.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
1/2"
HFO
011
030109
101CM2P
011-FE-0182
011-FT-0182
S
155
H
65
ATM. RESIDUE
Liquid
845
-0.90
396.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
1/2"
HFO
011
030109
101CM2P
011-FE-0182
011-FT-0182
S
155
H
65
ATM. RESIDUE
Liquid
845
-0.90
396.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
3/4"
HFO
011
030110
101CL4P
011-LG-0049-B
Reducer
S
155
H
65
ATM. RESIDUE
Gas
-
-0.83
391.00
-
-
3.50
-1.00
430.00
430.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
1"
HFO
011
030110
101CL4P
Reducer
1"-LFL-011030303-101CH2F-N
S
155
H
65
ATM. RESIDUE
Gas
-
-0.83
391.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
1"
HFO
011
030110
101CL4P
1"-HFO-011030110-101CL4P-S
Blind flange
S
155
H
65
ATM. RESIDUE
Gas
-
-0.83
391.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
18"
HFO
011
030111
101CL4P
011-C-0003
011-ZV-0016
S
155
H
100
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
4.60
-1.00
430.00
430.00
-
H
10.85
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
3/4"
HFO
011
030112
101CL4P
011-LG-0049-A
Reducer
S
155
H
65
ATM. RESIDUE
Gas
-
-0.83
391.00
-
-
3.50
-1.00
430.00
430.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
1"
HFO
011
030112
101CL4P
Reducer
1"-LFL-011030303-101CH2F-N
S
155
H
65
ATM. RESIDUE
Gas
-
-0.83
391.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
1"
HFO
011
030112
101CL4P
1"-HFO-011030112-101CL4P-S
Blind flange
S
155
H
65
ATM. RESIDUE
Gas
-
-0.83
391.00
-
-
3.50
-1.00
430.00
430.00
-
H
8.25
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200 ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200 ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200 ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200 ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200 ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200 ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200 ºC
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200 ºC
if insulated N or Q SA-JER-DS011-TRJR-480080
-
HFO
011
030601
103CL2P
011-C-0003
TRIM
S
22
H
-
-
-
-
-0.83
267.00
-
-
3.50
-1.00
370.00
370.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480080
2"
HFO
011
030601
103CL2P
011-C-0003
011-LT-0053
S
22
H
65
-
-
-
-0.83
267.00
-
-
3.50
-1.00
370.00
370.00
-
H
6.44
NFS
YES
SA-JER-DS011-TRJR-480080
2"
HFO
011
030601
103CL2P
011-C-0003
011-LG-0045
S
22
H
65
-
-
-
-0.83
267.00
-
-
3.50
-1.00
370.00
370.00
-
H
6.44
NFS
YES
SA-JER-DS011-TRJR-480080
2"
HFO
011
030601
103CL2P
011-C-0003
011-LG-0045
S
22
H
65
-
-
-
-0.83
267.00
-
-
3.50
-1.00
370.00
370.00
-
H
6.44
NFS
YES
SA-JER-DS011-TRJR-480080
2"
HFO
011
030601
103CL2P
011-C-0003
011-LT-0046
S
22
H
65
-
-
-
-0.83
267.00
-
-
3.50
-1.00
370.00
370.00
-
H
6.44
NFS
YES
SA-JER-DS011-TRJR-480080
2"
HFO
011
030601
103CL2P
011-C-0003
011-LT-0053
S
22
H
65
-
-
-
-0.83
267.00
-
-
3.50
-1.00
370.00
370.00
-
H
6.44
NFS
YES
SA-JER-DS011-TRJR-480080
2"
HFO
011
030601
103CL2P
011-C-0003
011-PT-0069
S
31
H
65
-
-
-
-0.83
267.00
-
-
3.50
-1.00
370.00
370.00
-
H
6.44
NFS
YES
SA-JER-DS011-TRJR-480080
2"
HFO
011
030601
103CL2P
011-C-0003
011-LT-0046
S
22
H
65
-
-
-
-0.83
267.00
-
-
3.50
-1.00
370.00
370.00
-
H
6.44
NFS
YES
SA-JER-DS011-TRJR-480081
-
HFO
011
030602
103SD0P
011-C-0003
TRIM
S
31
H
-
-
-
-
-0.83
322.00
-
-
3.50
-1.00
430.00
430.00
-
Visual Test
0.00
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200 ºC
SA-JER-DS011-TRJR-480081
2"
HFO
011
030602
103SD0P
011-C-0003
011-LT-0048
S
31
H
65
-
-
-
-0.83
322.00
-
-
3.50
-1.00
430.00
430.00
-
H
6.61
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200 ºC
SA-JER-DS011-TRJR-480081
2"
HFO
011
030602
103SD0P
011-C-0003
011-LT-0052
S
31
H
65
-
-
-
-0.83
322.00
-
-
3.50
-1.00
430.00
430.00
-
H
6.61
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200 ºC
SA-JER-DS011-TRJR-480081
2"
HFO
011
030602
103SD0P
011-C-0003
011-LG-0047
S
31
H
65
-
-
-
-0.83
322.00
-
-
3.50
-1.00
430.00
430.00
-
H
6.61
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200 ºC
SA-JER-DS011-TRJR-480081
2"
HFO
011
030602
103SD0P
011-C-0003
011-LT-0052
S
31
H
65
-
-
-
-0.83
322.00
-
-
3.50
-1.00
430.00
430.00
-
H
6.61
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200 ºC
SA-JER-DS011-TRJR-480081
2"
HFO
011
030602
103SD0P
011-C-0003
011-PT-0071
S
31
H
65
-
-
-
-0.83
322.00
-
-
3.50
-1.00
430.00
430.00
-
H
6.61
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200 ºC
SA-JER-DS011-TRJR-480081
2"
HFO
011
030602
103SD0P
011-C-0003
011-LG-0047
S
31
H
65
-
-
-
-0.83
322.00
-
-
3.50
-1.00
430.00
430.00
-
H
6.61
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200 ºC
SA-JER-DS011-TRJR-480081
2"
HFO
011
030602
103SD0P
011-C-0003
011-LT-0048
S
31
H
65
-
-
-
-0.83
322.00
-
-
3.50
-1.00
430.00
430.00
-
H
6.61
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200 ºC
SA-JER-DS011-TRJR-480099
8"
HFO
011
038001
103CL2P
8"-HFO-011030002-101CL2P-S
Reducer
S
22
H
100
MVGO
Liquid
775
1.90
267.00
-
170.00
30.00
-1.00
300.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
3/4"
HFO
011
038001
103CL2P
8"-HFO-011038001-103CL2P-S
011-PI-0236
S
22
H
65
MVGO
Liquid
775
1.90
267.00
-
170.00
30.00
-1.00
300.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
3/4"
HFO
011
038001
103CL2P
2"-HFO-011038001-103CL2P-S
Blind flange
S
22
H
65
MVGO
Liquid
775
1.90
267.00
-
170.00
30.00
-1.00
300.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
3/4"
HFO
011
038001
103CL2P
8"-HFO-011038001-103CL2P-S
UC
S
22
H
65
MVGO
Liquid
775
1.90
267.00
-
170.00
30.00
-1.00
300.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
2"
HFO
011
038001
103CL2P
2"-FLO-011038302-101CS1P-N
8"-HFO-011038001-103CL2P-S
S
22
H
65
MVGO
Liquid
775
1.90
267.00
-
170.00
30.00
-1.00
300.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
6"
HFO
011
038001
103CL2P
Reducer
011-G-0016-A
S
22
H
100
MVGO
Liquid
775
1.90
267.00
-
170.00
30.00
-1.00
300.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q
SA-JER-DS011-TRJR-480099
8"
HFO
011
038002
103CL2P
8"-HFO-011030002-101CL2P-S
Reducer
S
22
H
100
MVGO
Liquid
775
1.90
267.00
-
170.00
30.00
-1.00
300.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
3/4"
HFO
011
038002
103CL2P
8"-HFO-011038002-103CL2P-S
UC
S
22
H
65
MVGO
Liquid
775
1.90
267.00
-
170.00
30.00
-1.00
300.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
3/4"
HFO
011
038002
103CL2P
8"-HFO-011038002-103CL2P-S
011-PI-0247
S
22
H
65
MVGO
Liquid
775
1.90
267.00
-
170.00
30.00
-1.00
300.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
3/4"
HFO
011
038002
103CL2P
2"-HFO-011038002-103CL2P-S
Blind flange
S
22
H
65
MVGO
Liquid
775
1.90
267.00
-
170.00
30.00
-1.00
300.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
2"
HFO
011
038002
103CL2P
2"-FLO-011038303-101CS1P-N
8"-HFO-011038002-103CL2P-S
S
22
H
65
MVGO
Liquid
775
1.90
267.00
-
170.00
30.00
-1.00
300.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
6"
HFO
011
038002
103CL2P
Reducer
011-G-0016-B
S
22
H
100
MVGO
Liquid
775
1.90
267.00
-
170.00
30.00
-1.00
300.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
3"
HFO
011
038003
103CL2P
011-G-0016-A
Reducer
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
300.00
Page 93 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
TO
TYPE S
TEMP. (ºC) 22
INSULATION (NOTE 2)
TYPE
THICKNESS (mm)
H
100
FLUID
PHASE
(NOTE 3)
DENSITY (kg/m3)
(NOTE 4) 775
OPERATING CONDITIONS PRESS. (BARG) 19.60
TEMP. (ºC) 267.00
DESIGN CONDITIONS
ALTERNATE CONDITIONS PRESS. (BARG) -
TEMP. (ºC) 170.00
PRESS. (BARG) 30.00
TEMP. (ºC) 300.00
STRESS TEMP
(ºC) -
TEST CONDITIONS
MEDIUM (NOTE 5) H
PRESS. (BARG) 53.31
FLUID CATEGORY (ASME B.31.3)
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6) NFS
SA-JER-DS011-TRJR-380001
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480099
6"
HFO
011
038003
103CL2P
Reducer
Reducer
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
3/4"
HFO
011
038003
103CL2P
6"-HFO-011038003-103CL2P-S
6"-HFO-011038003-103CL2P-S
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
3/4"
HFO
011
038003
103CL2P
6"-HFO-011038003-103CL2P-S
011-PI-0087
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
6"
HFO
011
038003
103CL2P
6"-HFO-011038003-103CL2P-S
Reducer
S
22
H
100
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
1/2"
HFO
011
038003
103CL2P
011-FE-0155-A
011-FT-0155-A
S
22
H
40
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
4"
HFO
011
038003
103CL2P
Reducer
4"-HFO-011038003-103CL2P-S
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
1/2"
HFO
011
038003
103CL2P
011-FE-0155-A
011-FT-0155-B
S
22
H
40
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
1/2"
HFO
011
038003
103CL2P
011-FE-0155-A
011-FT-0155-B
S
22
H
40
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
1/2"
HFO
011
038003
103CL2P
011-FE-0155-A
011-FT-0155-A
S
22
H
40
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480024
6"
HFO
011
038003
103CL2P
SA-JER-DS011-TRJR-480099
12"-HFO-011013001-103CL2P-S
S
22
H
100
MVGO
Liquid
775
18.32
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
4"
HFO
011
038003
103CL2P
Reducer
Reducer
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
6"
HFO
011
038003
103CL2P
Reducer
6"-HFO-011038003-103CL2P-S
S
22
H
100
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
6"
HFO
011
038003
103CL2P
6"-HFO-011038003-103CL2P-S
SA-JER-DS011-TRJR-480024
S
22
H
100
MVGO
Liquid
775
18.32
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
6"
HFO
011
038003
103CL2P
Reducer
6"-HFO-011038003-103CL2P-S
S
22
H
100
MVGO
Liquid
775
18.32
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
4"-HFO-011038003-103CL2P-S
Reducer
S
22
H
65
MVGO
Liquid
775
18.32
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
22
H
65
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
MVGO
Liquid
DOC. No.
YES
N or Q
SA-JER-DS011-TRJR-480099
4"
HFO
011
038003
103CL2P
SA-JER-DS011-TRJR-480099
3/4"
HFO
011
038003
103CL2P
6"-HFO-011038003-103CL2P-S
3/4"-HFO-011038012-103CL2P-S
S
MVGO
Liquid
SA-JER-DS011-TRJR-480100
12"
HFO
011
038004
103CS1P
12"-HFO-011008001-103CS1P-S
SA-JER-DS011-TRJR-480137
S
31
H
65
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
3/4"
HFO
011
038004
103CS1P
12"-HFO-011038004-103CS1P-S
011-PI-0182
S
31
H
40
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
2"
HFO
011
038004
103CS1P
2"-FLO-011038305-101CS1P-N
12"-HFO-011038004-103CS1P-S
S
31
H
40
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
1/2"
HFO
011
038004
103CS1P
011-FE-0183
011-FT-0183
S
31
H
25
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
1/2"
HFO
011
038004
103CS1P
011-FE-0183
011-FT-0183
S
31
H
25
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
3/4"
HFO
011
038004
103CS1P
011-PT-0338
12"-HFO-011038004-103CS1P-S
S
31
H
40
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
3/4"
HFO
011
038004
103CS1P
2"-HFO-011038004-103CS1P-S
Plug
S
31
H
40
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
12"
HFO
011
038004
103CS1P
SA-JER-DS011-TRJR-480100
IP-1304-L
S
31
H
65
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
2"
HFO
011
038004
103CS1P
12"-HFO-011038004-103CS1P-S
Blind flange
S
31
H
40
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
10"
HFO
011
038005
103CS1P
011-E-0030-B
Reducer
S
31
H
40
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
8"
HFO
011
038005
103CS1P
Reducer
Reducer
S
31
H
40
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
1/2"
HFO
011
038005
103CS1P
011-FT-0050-B
011-FE-0050
S
31
H
25
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
1/2"
HFO
011
038005
103CS1P
011-FT-0050-A
011-FE-0050
S
31
H
25
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
8"
HFO
011
038005
103CS1P
8"-HFO-011038005-103CS1P-S
Reducer
S
31
H
40
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
6"
HFO
011
038005
103CS1P
Reducer
6"-HFO-011038005-103CS1P-S
S
31
H
40
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
1/2"
HFO
011
038005
103CS1P
011-FT-0050-A
011-FE-0050
S
31
H
25
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
1/2"
HFO
011
038005
103CS1P
011-FT-0050-B
011-FE-0050
S
31
H
25
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480138
8"
HFO
011
038005
103CS1P
SA-JER-DS011-TRJR-480100
IP-1318-L
S
31
H
40
HVGO
Liquid
894
7.00
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480138
3/4"
HFO
011
038005
103CS1P
8"-HFO-011038005-103CS1P-S
011-PI-0183
S
31
H
25
HVGO
Liquid
894
7.00
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480138
3/4"
HFO
011
038005
103CS1P
8"-HFO-011038005-103CS1P-S
Plug
S
31
H
25
HVGO
Liquid
894
7.00
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480138
2"
HFO
011
038005
103CS1P
8"-HFO-011038005-103CS1P-S
011-TT-0472
S
31
H
25
HVGO
Liquid
894
7.00
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
3/4"
HFO
011
038005
103CS1P
2"-HFO-011038005-103CS1P-S
Plug
S
31
H
25
HVGO
Liquid
894
7.00
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
6"
HFO
011
038005
103CS1P
Reducer
Reducer
S
31
H
40
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
8"
HFO
011
038005
103CS1P
Reducer
8"-HFO-011038005-103CS1P-S
S
31
H
40
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
8"
HFO
011
038005
103CS1P
8"-HFO-011038005-103CS1P-S
SA-JER-DS011-TRJR-480138
S
31
H
40
HVGO
Liquid
894
7.00
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
2"
HFO
011
038005
103CS1P
2"-HFO-011038005-103CS1P-S
8"-HFO-011038005-103CS1P-S
S
31
H
25
HVGO
Liquid
894
7.00
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
8"
HFO
011
038005
103CS1P
Reducer
8"-HFO-011038005-103CS1P-S
S
31
H
40
HVGO
Liquid
894
7.00
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
6"
HFO
011
038005
103CS1P
6"-HFO-011038005-103CS1P-S
Reducer
S
31
H
40
HVGO
Liquid
894
7.00
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
2"
HFO
011
038005
103CS1P
2"-FLO-011038306-101CS1P-N
2"-HFO-011038005-103CS1P-S
S
31
H
25
HVGO
Liquid
894
7.00
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
3"
HFO
011
038007
103CL2P
011-G-0016-B
Reducer
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
6"
HFO
011
038007
103CL2P
Reducer
6"-HFO-011038007-103CL2P-S
S
22
H
100
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
3/4"
HFO
011
038007
103CL2P
6"-HFO-011038007-103CL2P-S
011-PI-0088
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
3/4"
HFO
011
038007
103CL2P
6"-HFO-011038007-103CL2P-S
6"-HFO-011038007-103CL2P-S
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
6"
HFO
011
038007
103CL2P
6"-HFO-011038007-103CL2P-S
6"-HFO-011038003-103CL2P-S
S
22
H
100
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
3/4"
HFO
011
038009
103CL2P
011-SC-0046
6"-HFO-011038003-103CL2P-S
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
HFO
011
038009
103CL2P
SA-JER-DS011-TRJR-480099
3/4"
HFO
011
038011
103CL2P
SA-JER-DS011-TRJR-480274
3/4"
HFO
011
038011
103CL2P
SA-JER-DS011-TRJR-480099
1-1/2"
HFO
011
038012
103CL2P
SA-JER-DS011-TRJR-480099
3/4"
HFO
011
038012
103CL2P
SA-JER-DS011-TRJR-480099
2"
HFO
011
038012
103CL2P
3/4"-HFO-011200002-103CL2P-N 6"-HGO-0110380031-103CL2P-S 6"-HFO-011038003-103CL2P-S
011-SC-0046
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
MVGO
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
NOTE 6
267.00
-
-
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
6"-HFO-011038003-103CL2P-S
Reducer
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
1-1/2"-HFO-011038012-103CL2P- 3/4"-OLW-011038301-101CS1PS N Reducer
2"-CLD-011038301-101CH2S-P
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
011
038012
103CL2P
011-G-0016-A
Reducer
SA-JER-DS011-TRJR-480099
1"
HFO
011
038012
103CL2P
SA-JER-DS011-TRJR-480099
3/4"
HFO
011
038012
103CL2P
SA-JER-DS011-TRJR-480099
1-1/2"
HFO
011
038013
103CL2P
103CL2P
30.00
-
19.60
HFO
038013
170.00
775
3/4"
011
-
Liquid
SA-JER-DS011-TRJR-480099
HFO
267.00 267.00
MVGO
8"-HFO-011038001-103CL2P-S
2"
18.32 18.32
65
103CL2P
SA-JER-DS011-TRJR-480099
775 775
H
038012
103CL2P
Liquid Liquid
22
011
038013
MVGO
S
HFO
011
65 65
SAMPLE COOLER
1-1/2"
HFO
H H
6"-HGO-0110380031-103CL2P-S
SA-JER-DS011-TRJR-480099
3/4"
22 22
THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE.
1-1/2"-HFO-011038012-103CL2PS
SA-JER-DS011-TRJR-480099
S S
1-1/2"-HFO-011038012-103CL2PS 1-1/2"-HFO-011038012-103CL2P3/4"-HFO-011038003-103CL2P-S S Reducer
6"-HFO-011038007-103CL2P-S
Reducer
1-1/2"-HFO-011038013-103CL2P- 3/4"-OLW-011038302-101CS1PS N Reducer
2"-CLD-011038302-101CH2S-P
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
1-1/2"
HFO
011
038013
103CL2P
8"-HFO-011038002-103CL2P-S
1-1/2"-HFO-011038013-103CL2PS
SA-JER-DS011-TRJR-480099
3/4"
HFO
011
038013
103CL2P
011-G-0016-B
Reducer
SA-JER-DS011-TRJR-480099
1"
HFO
011
038013
103CL2P
SA-JER-DS011-TRJR-480099
3/4"
HFO
011
038013
103CL2P
SA-JER-DS011-TRJR-480099
3/4"
HFO
011
038014
103CL2P
6"-HFO-011038003-103CL2P-S
Reducer
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
3/4"
HFO
011
038014
103CL2P
3/4"-HFO-011038014-103CL2P-S
Blind flange
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
2"
HFO
011
038014
103CL2P
Reducer
2"-CLD-011038303-101CH2S-P
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480099
3/4"
HFO
011
038014
103CL2P
6"-HFO-011038003-103CL2P-S
3/4"-HFO-011038014-103CL2P-S
S
22
H
65
MVGO
Liquid
775
19.60
267.00
-
170.00
30.00
300.00
-
H
53.31
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
2"
HFO
011
038015
103CS1P
8"-HFO-011038005-103CS1P-S
2"-HFO-011038015-103CS1P-S
S
31
H
25
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
2"
HFO
011
038015
103CS1P
2"-HFO-011038015-103CS1P-S
Blind flange
S
31
H
25
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
2"
HFO
011
038015
103CS1P
2"-HFO-011038015-103CS1P-S
2"-CLD-011038307-101CH2S-P
S
31
H
25
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
3/4"
HFO
011
038016
103CS1P
8"-HFO-011038005-103CS1P-S
Reducer
S
31
H
25
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
3/4"
HFO
011
038016
103CS1P 3/4"-HFO-011038016-103CS1P-S
Plug
S
31
H
25
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
2"
HFO
011
038016
103CS1P
Reducer
2"-CLD-011038304-101CH2S-P
S
31
H
25
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
3/4"
HFO
011
038016
103CS1P
8"-HFO-011038005-103CS1P-S
3/4"-HFO-011038016-103CS1P-S
S
31
H
25
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
3/4"
HFO
011
038017
103CS1P
12"-HFO-011008001-103CS1P-S
011-SC-0008
S
31
H
40
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
HFO
011
038017
103CS1P
8"-HGO-011038001-103CS1P-S
SAMPLE COOLER
S
31
H
40
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE.NOTE 6.
SA-JER-DS011-TRJR-480100
3/4"
HFO
011
038018
103CS1P
011-SC-0008
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
HFO
011
038018
103CS1P 3/4"-HFO-011200103-103CS1P-N
SA-JER-DS011-TRJR-480100
2"
HFO
011
038020
103CS1P
UC
SA-JER-DS011-TRJR-480100
3/4"
HFO
011
038020
103CS1P
2"-HFO-011038020-103CS1P-P
Plug
-
SA-JER-DS011-TRJR-480100
2"
HFO
011
038020
103CS1P
Insul Brk
8"-HFO-011038005-103CS1P-S
S
SA-JER-DS011-TRJR-480100
8"
HFO
011
038021
103CS1P
8"-HFO-011038005-103CS1P-S
8"-HFO-011038021-103CS1P-S
S
31
SA-JER-DS011-TRJR-380001
1-1/2"-HFO-011038013-103CL2PS 1-1/2"-HFO-011038013-103CL2P3/4"-HFO-011038007-103CL2P-S S Reducer
8"-HFO-011038005-103CS1P-S
S
31
H
25
HVGO
Liquid
894
7.00
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
8"-HGO-011038005-103CS1P-S
S
31
H
25
HVGO
Liquid
894
7.00
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
Insul Brk
-
-
P
25
HVGO
Liquid
894
11.56
90.00
-
-
30.00
118.00
-
H
45.00
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
ALTERNATE CONDITIONS FV@290ºC
-
P
25
HVGO
Liquid
894
11.56
90.00
-
-
30.00
118.00
-
H
45.00
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
ALTERNATE CONDITIONS FV@290ºC
31
H
25
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE CONDITIONS FV@290ºC
H
40
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
Page 94 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
INSULATION (NOTE 2)
TYPE
FLUID
THICKNESS (mm)
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480100
8"
HFO
011
038021
103CS1P
8"-HFO-011038021-103CS1P-S
12"-HFO-011038004-103CS1P-S
S
31
H
65
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
2"
HFO
011
038022
103CS1P
8"-HFO-011008001-103CS1P-S
2"-CLD-011038307-101CH2S-P
S
31
H
40
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
2"
HFO
011
038022
103CS1P
2"-HFO-011038022-103CS1P-S
Blind flange
S
31
H
40
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
10"
HFO
011
038023
103CS1P
10"-HFO-011038005-103CS1P-S
Reducer
S
31
H
40
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
12"
HFO
011
038023
103CS1P
Reducer
12"-HFO-011038023-103CS1P-S
S
31
H
40
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480100
12"
HFO
011
038023
103CS1P
12"-HFO-011038023-103CS1P-S
SA-JER-DS011-TRJR-480104
S
155
H
40
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480100
3/4"
HFO
011
038023
103CS1P
12"-HFO-011038023-103CS1P-S
Blind flange
S
155
H
25
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
12"
HFO
011
038023
103CS1P
SA-JER-DS011-TRJR-480100
12"-HFO-011040106-103CS1P-S
S
155
H
40
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480100
2"
HFO
011
038023
103CS1P
2"-FLO-011038308-101CS1P-N
12"-HFO-011038023-103CS1P-S
S
155
H
25
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480100
3/4"
HFO
011
038023
103CS1P
2"-HFO-011038023-103CS1P-S
Blind flange
S
155
H
25
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480100
2"
HFO
011
038024
103CS1P
2"-HFO-011038024-103CS1P-S
Blind flange
S
31
H
25
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
2"
HFO
011
038024
103CS1P
10"-HFO-011038005-103CS1P-S
2"-CLD-011038309-101CH2S-P
S
31
H
25
HVGO
Liquid
894
11.56
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
N
POTENTIAL
N
N
N
N
-
NOTE 6
if insulated N or Q -
HFO
011
038601
106CS1P
011-E-0030 A/B
TRIM
-
-
H
-
SA-JER-DS011-TRJR-480101
20"
HFO
011
039001
103CL2P
SA-JER-DS011-TRJR-480101
3/4"
HFO
011
039001
103CL2P
20"-HFO-011030001-101CL2P-S
Reducer
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
20"-HFO-011039001-103CL2P-S
011-PDT-0106
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480101
3/4"
HFO
011
039001
103CL2P
NOTE 6
2"-HFO-011039001-103CL2P-S
Plug
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480101
3/4"
HFO
011
039001
SA-JER-DS011-TRJR-480101
20"
HFO
011
039001
NOTE 6
103CL2P
20"-HFO-011039001-103CL2P-S
011-PI-0368
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
103CL2P
20"-HFO-011039001-103CL2P-S
Blind flange
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480101
3/4"
HFO
011
039001
NOTE 6
103CL2P
20"-HFO-011039001-103CL2P-S
011-PDT-0106
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480101
2"
HFO
011
NOTE 6
039001
103CL2P
2"-FLO-011039302-101CS1P-N
20"-HFO-011039001-103CL2P-S
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480101
16"
HFO
NOTE 6
011
039001
103CL2P
Reducer
011-G-0017-A
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480101
20"
NOTE 6
HFO
011
039002
103CL2P
20"-HFO-011030001-101CL2P-S
Reducer
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480101
3/4"
NOTE 6
HFO
011
039002
103CL2P
20"-HFO-011039002-103CL2P-S
011-PDT-0107
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480101
3/4"
HFO
011
039002
SA-JER-DS011-TRJR-480101
20"
HFO
011
039002
NOTE 6
103CL2P
20"-HFO-011039002-103CL2P-S
011-PI-0369
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
103CL2P
20"-HFO-011039002-103CL2P-S
Blind flange
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480101
3/4"
HFO
011
039002
NOTE 6
103CL2P
20"-HFO-011039002-103CL2P-S
011-PDT-0107
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480101
2"
HFO
011
NOTE 6
039002
103CL2P
2"-FLO-011039303-101CS1P-N
20"-HFO-011039002-103CL2P-S
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480101
3/4"
HFO
NOTE 6
011
039002
103CL2P
2"-HFO-011039002-103CL2P-S
Plug
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480101
16"
NOTE 6
HFO
011
039002
103CL2P
Reducer
011-G-0017-B
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480101
NOTE 6
10"
HFO
011
039003
103CL2P
011-G-0017-A
Reducer
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
16"
HFO
011
039003
103CL2P
Reducer
16"-HFO-011039003-103CL2P-S
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
3/4"
HFO
011
039003
103CL2P
16"-HFO-011039003-103CL2P-S
011-PI-0089
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
3/4"
HFO
011
039003
103CL2P
16"-HFO-011039003-103CL2P-S
16"-HFO-011039003-103CL2P-S
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
18"
HFO
011
039003
103CL2P
SA-JER-DS011-TRJR-480101
Reducer
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
1/2"
HFO
011
039003
103CL2P
011-FT-0064
011-FE-0011
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
1/2"
HFO
011
039003
103CL2P
011-FT-0064
011-FE-0011
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
18"
HFO
011
039003
103CL2P
18"-HFO-011039003-103CL2P-S
Reducer
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
12"
HFO
011
039003
103CL2P
Reducer
12"-HFO-011039003-103CL2P-S
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
12"
HFO
011
039003
103CL2P
Reducer
12"-HFO-011039003-103CL2P-S
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
12"
HFO
011
039003
103CL2P
12"-HFO-011039003-103CL2P-S
011-E-0019-A/D
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
039003
103CL2P
2"-FLO-011015302-101CS1P-N
2"-HFO-011039003-103CL2P-S
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
039003
103CL2P
2"-FLO-011015304-101CS1P-N
2"-HFO-011039003-103CL2P-S
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
3/4"
HFO
011
039003
103CL2P
2"-HFO-011039003-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
039003
103CL2P
12"-HFO-011039003-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
12"
HFO
011
039003
103CL2P
12"-HFO-011039003-103CL2P-S
011-E-0019-D
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
3/4"
HFO
011
039003
103CL2P
2"-HFO-011039003-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
039003
103CL2P
12"-HFO-011039003-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
039003
103CL2P
2"-HFO-011039003-103CL2P-S
12"-HFO-011039003-103CL2P-S
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480028
2"
HFO
011
039003
103CL2P
2"-HFO-011039003-103CL2P-S
12"-HFO-011039003-103CL2P-S
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
33.10
355.00
-
H
60.28
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
16"
HFO
011
039003
103CL2P
16"-HFO-011039003-103CL2P-S
Reducer
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
18"
HFO
011
039003
103CL2P
Reducer
SA-JER-DS011-TRJR-480028
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
6"
HFO
011
039004
103CL2P
18"-HFO-011039003-103CL2P-S
SA-JER-DS011-TRJR-480102
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
6"
HFO
011
039004
103CL2P
SA-JER-DS011-TRJR-480101
Reducer
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
1/2"
HFO
011
039004
103CL2P
011-FE-0051
011-FT-0051-A
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
1/2"
HFO
011
039004
103CL2P
011-FE-0051
011-FT-0051-B
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
6"
HFO
011
039004
103CL2P
6"-HFO-011039004-103CL2P-S
Reducer
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
2"
HFO
011
039004
103CL2P
Reducer
2"-HFO-011039004-103CL2P-S
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
1/2"
HFO
011
039004
103CL2P
011-FE-0051
011-FT-0051-A
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
1/2"
HFO
011
039004
103CL2P
011-FE-0051
011-FT-0051-B
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
4"
HFO
011
039004
103CL2P
Reducer
Reducer
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
6"
HFO
011
039004
103CL2P
Reducer
6"-HFO-011039004-103CL2P-S
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
4"
HFO
011
039004
103CL2P
6"-HFO-011039004-103CL2P-S
Blind flange
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
6"
HFO
011
039004
103CL2P
6"-HFO-011039004-103CL2P-S
011-S-0002
S
31
H
100
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
3/4"
HFO
011
039004
103CL2P
6"-HFO-011039004-103CL2P-S
011-PI-0317
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
3/4"
HFO
011
039004
103CL2P
6"-HFO-011039004-103CL2P-S
011-PDT-0091
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
3/4"
HFO
011
039004
103CL2P
2"-HFO-011039004-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
3/4"
HFO
011
039004
103CL2P
6"-HFO-011039004-103CL2P-S
3/4"-HFO-011039015-103SD0P-S
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
2"
HFO
011
039004
103CL2P
2"-FLO-011039304-101CS1P-N
6"-HFO-011039004-103CL2P-S
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
2"
HFO
011
039004
103CL2P
2"-HFO-011039004-103CL2P-S
Reducer
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
6"
HFO
011
039004
103CL2P
Reducer
6"-HFO-011039004-103CL2P-S
S
31
H
100
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
10"
HFO
011
039005
103CL2P
18"-HFO-011039003-103CL2P-S
SA-JER-DS011-TRJR-480141
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
10"
HFO
011
039005
103CL2P
SA-JER-DS011-TRJR-480101
10"-HFO-011039005-103CL2P-S
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
10"
HFO
011
039005
103CL2P
10"-HFO-011039005-103CL2P-S
10"-HFO-011039005-103CL2P-S
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
10"
HFO
011
039005
103CL2P
10"-HFO-011039005-103CL2P-S
14"-HFO-011013003-103CL2P-S
S
31
H
100
HVGO
Liquid
775
18.99
252.00
-
-
30.00
325.00
-
H
53.79
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480141
10"
HFO
011
039005
103CL2P
10"-HFO-011039005-103CL2P-S
10"-HFO-011039005-103CL2P-S
S
31
H
100
HVGO
Liquid
775
18.99
252.00
-
-
30.00
325.00
-
H
53.79
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
6"
HFO
011
039006
101SD0P
6"-HFO-011039018-103SD0P-S
6"-HFO-011039008-101SD0P-S
S
31
HA
100
HVGO
Liquid
775
2.65
322.00
-
-
6.32
-1.00
355.00
355.00
-
H
11.47
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
6"
HFO
011
039007
101SD0P
6"-HFO-011039019-103SD0P-S
6"-HFO-011039008-101SD0P-S
S
31
H
100
HVGO
Liquid
775
2.65
322.00
-
-
6.32
-1.00
355.00
355.00
-
H
11.47
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
6"
HFO
011
039008
101SD0P
6"-HFO-011039006-101SD0P-HA
SA-JER-DS011-TRJR-480081
S
31
H
100
HVGO
Liquid
775
2.65
322.00
-
-
6.32
-1.00
355.00
355.00
-
H
11.47
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
3/4"
HFO
011
039008
101SD0P
6"-HFO-011039008-101SD0P-S
011-PI-0318
S
31
H
65
HVGO
Liquid
775
2.65
322.00
-
-
6.32
-1.00
355.00
355.00
-
H
11.47
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
3/4"
HFO
011
039008
101SD0P
6"-HFO-011039008-101SD0P-S
011-PDT-0091
S
31
H
65
HVGO
Liquid
775
2.65
322.00
-
-
6.32
-1.00
355.00
355.00
-
H
11.47
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
3/4"
HFO
011
039008
101SD0P
6"-HFO-011039008-101SD0P-S
011-PT-0041
S
31
H
65
HVGO
Liquid
775
2.65
322.00
-
-
6.32
-1.00
355.00
355.00
-
H
11.47
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480081
6"
HFO
011
039008
101SD0P
SA-JER-DS011-TRJR-480102
011-C-0003
S
31
H
100
HVGO
Liquid
775
2.65
322.00
-
-
6.32
-1.00
355.00
355.00
-
H
11.47
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
10"
HFO
011
039010
103CL2P
011-G-0017-B
Reducer
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
16"
HFO
011
039010
103CL2P
Reducer
16"-HFO-011039010-103CL2P-S
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
3/4"
HFO
011
039010
103CL2P
16"-HFO-011039010-103CL2P-S
16"-HFO-011039010-103CL2P-S
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
3/4"
HFO
011
039010
103CL2P
16"-HFO-011039010-103CL2P-S
011-PI-0090
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
16"
HFO
011
039010
103CL2P
16"-HFO-011039010-103CL2P-S
Reducer
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
18"
HFO
011
039010
103CL2P
Reducer
18"-HFO-011039003-103CL2P-S
S
31
H
100
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480100
SA-JER-DS011-TRJR-380001
-
-
-
12.60
160.00
-
-
30.00
210.00
-
355.00
Visual Test
0.00
NFS
By Code
if NOT insulated B or Q
Page 95 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
INSULATION (NOTE 2)
TYPE
FLUID
THICKNESS (mm)
PHASE
(NOTE 3)
DOC. No.
DENSITY (kg/m3)
(NOTE 4)
OPERATING CONDITIONS PRESS. (BARG)
TEMP. (ºC)
DESIGN CONDITIONS
ALTERNATE CONDITIONS PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
(ºC)
TEST CONDITIONS
MEDIUM (NOTE 5)
PRESS. (BARG)
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6)
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480101
2"
HFO
011
039011
103CL2P
16"-HFO-011039003-103CL2P-S
2"-CLD-011039301-101CH2S-P
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
3/4"
HFO
011
039011
103CL2P
2"-HFO-011039011-103CL2P-S
3/4"-OLW-011039001-101CS1PN
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
3/4"
HFO
011
039011
103CL2P
011-G-0017-A
Reducer
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
2"
HFO
011
039011
103CL2P
Reducer
2"-HFO-011039011-103CL2P-S
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
2"
HFO
011
039011
103CL2P
16"-HFO-011039001-103CL2P-S
2"-HFO-011039011-103CL2P-S
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
3/4"
HFO
011
039011
103CL2P
20"-HFO-011039001-103CL2P-S
2"-HFO-011039011-103CL2P-S
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
2"
HFO
011
039012
103CL2P
16"-HFO-011039010-103CL2P-S
2"-CLD-011039302-101CH2S-P
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
3/4"
HFO
011
039012
103CL2P
2"-HFO-011039012-103CL2P-S
3/4"-OLW-011039002-101CS1PN
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
3/4"
HFO
011
039012
103CL2P
011-G-0017-B
Reducer
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
2"
HFO
011
039012
103CL2P
Reducer
2"-HFO-011039012-103CL2P-S
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
2"
HFO
011
039012
103CL2P
16"-HFO-011039002-103CL2P-S
2"-HFO-011039012-103CL2P-S
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480101
3/4"
HFO
011
039012
103CL2P
20"-HFO-011039002-103CL2P-S
2"-HFO-011039012-103CL2P-S
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
6"
HFO
011
039013
103CL2P
6"-HFO-011039004-103CL2P-S
6"-HFO-011039019-103SD0P-S
S
31
H
100
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
2"
HFO
011
039013
103CL2P
2"-FLO-011039305-101CS1P-N
6"-HFO-011039013-103CL2P-S
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480102
3/4"
HFO
011
039013
103CL2P
2"-HFO-011039013-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
-1.00
NOTE 6 NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 425ºC NOTE 6, 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 425ºC NOTE 6, 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 425ºC NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 425ºC NOTE 6, 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 425ºC NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 425ºC NOTE 10
Reducer
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.44
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
2"-HFO-011039014-103SD0P-S
Blind flange
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.44
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
Reducer
011-PZV-0070
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.44
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
103SD0P
2"-HFO-011039014-103SD0P-S
2"-HFO-011039014-103SD0P-S
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.44
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
039014
103SD0P
2"-HFO-011039014-103SD0P-S
2"-LFL-011039301-101CH2F-N
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.44
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
011
039014
103SD0P
2"-HFO-011039014-103SD0P-S
Blind flange
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.44
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
HFO
011
039015
103SD0P
011-S-0002
Reducer
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.44
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
4"
HFO
011
039015
103SD0P
Reducer
Reducer
S
31
H
100
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.44
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
2"
HFO
011
039015
103SD0P
Reducer
2"-CLD-011039304-101CH2S-P
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.44
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
3/4"
HFO
011
039015
103SD0P
2"-HFO-011039015-103SD0P-S
3/4"-OLW-011039003-101CS1PN
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.44
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
2"
HFO
011
039016
103CL2P
Reducer
2"-CLD-011039305-101CH2S-P
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
3/4"
HFO
011
039016
103CL2P
6"-HFO-011039019-103SD0P-S
Reducer
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
3/4"
HFO
011
039016
103CL2P
3/4"-HFO-011039016-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
3/4"
HFO
011
039017
103CL2P
6"-HFO-011039004-103CL2P-S
Reducer
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
3/4"
HFO
011
039017
103CL2P
3/4"-HFO-011039017-103CL2P-S
Blind flange
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
2"
HFO
011
039017
103CL2P
Reducer
2"-CLD-011039303-101CH2S-P
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
355.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
3/4"
HFO
011
039017
103CL2P
6"-HFO-011039004-103CL2P-S
3/4"-HFO-011039017-103CL2P-S
S
31
H
65
HVGO
Liquid
775
19.51
322.00
-
-
30.00
-
H
54.63
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
6"
HFO
011
039018
103SD0P
011-S-0002
6"-HFO-011039006-101SD0P-HA
S
31
H
100
HVGO
Liquid
775
2.65
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.44
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
3/4"
HFO
011
039018
103SD0P
6"-HFO-011039018-103SD0P-S
2"-HFO-011039015-103SD0P-S
S
31
H
65
HVGO
Liquid
775
2.65
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.44
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
3/4"
HFO
011
039018
103SD0P
6"-HFO-011039018-103SD0P-S
011-PI-0453
S
31
H
65
HVGO
Liquid
775
2.65
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.44
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
6"
HFO
011
039019
103SD0P
6"-HFO-011039019-103SD0P-S
6"-HFO-011039007-101SD0P-S
S
31
H
100
HVGO
Liquid
775
3.40
322.00
-
-
30.00
-1.00
355.00
355.00
-
H
54.44
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
6"
HFO
011
039019
103SD0P
6"-HFO-011039019-103SD0P-S
Blind flange
S
31
H
100
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.44
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480102
2"
HFO
011
039022
103SD0P
UC
011-S-0002
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
355.00
-
H
54.44
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@290ºC.
SA-JER-DS011-TRJR-480102
3/4"
HFO
011
039022
103SD0P
2"-HFO-011039022-103SD0P-S
Blind flange
S
31
H
65
HVGO
Liquid
775
3.40
322.00
-
-
30.00
-
H
54.44
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@290ºC.
SA-JER-DS011-TRJR-480103
16"
HFO
011
039101
103CL4P
16"-HFO-011030101-103CL4P-S
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
1"
HFO
011
039101
103CL4P
16"-HFO-011039101-103CL4P-S
011-PDT-0108
S
155
H
65
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
1"
HFO
011
039101
103CL4P
16"-HFO-011039101-103CL4P-S
011-PDT-0108
S
155
H
65
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
1"
HFO
011
039101
103CL4P
16"-HFO-011039101-103CL4P-S
011-PI-0370
S
155
H
65
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
2"
HFO
011
039101
103CL4P
16"-HFO-011039101-103CL4P-S
UC
S
155
H
75
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
2"
HFO
011
039101
103CL4P
2"-FLO-011039307-101CS1P-N
16"-HFO-011039101-103CL4P-S
S
155
H
75
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
2"-HFO-011039101-103CL4P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
155
H
100
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480102
2"
HFO
011
039014
103SD0P
011-S-0002
SA-JER-DS011-TRJR-480102
3/4"
HFO
011
039014
103SD0P
SA-JER-DS011-TRJR-480102
1"
HFO
011
039014
103SD0P
SA-JER-DS011-TRJR-480102
2"
HFO
011
039014
SA-JER-DS011-TRJR-480102
2"
HFO
011
SA-JER-DS011-TRJR-480102
3/4"
HFO
SA-JER-DS011-TRJR-480102
2"
SA-JER-DS011-TRJR-480102
355.00
355.00
SA-JER-DS011-TRJR-480103
1"
HFO
011
039101
103CL4P
SA-JER-DS011-TRJR-480103
12"
HFO
011
039101
103CL4P
Reducer
011-G-0018-A
S
VACUUM RESIDUE
Liquid
SA-JER-DS011-TRJR-480103
16"
HFO
011
039102
103CL4P
16"-HFO-011030101-103CL4P-S
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
1"
HFO
011
039102
103CL4P
2"-HFO-011039102-103CL4P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
2"
HFO
011
039102
103CL4P
16"-HFO-011039102-103CL4P-S
UC
S
155
H
75
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
1"
HFO
011
039102
103CL4P
16"-HFO-011039102-103CL4P-S
011-PDT-0109
S
155
H
65
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
1"
HFO
011
039102
103CL4P
16"-HFO-011039102-103CL4P-S
011-PDT-0109
S
155
H
65
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
2"
HFO
011
039102
103CL4P
2"-FLO-011039308-101CS1P-N
16"-HFO-011039102-103CL4P-S
S
155
H
75
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
1"
HFO
011
039102
103CL4P
16"-HFO-011039102-103CL4P-S
011-PI-0371
S
155
H
65
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
12"
HFO
011
039102
103CL4P
Reducer
011-G-0018-B
S
155
H
100
VACUUM RESIDUE
Liquid
880
-0.83
360.00
-
-
28.00
-1.00
390.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
10"
HFO
011
039103
103CL4P
011-G-0018-A
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
12"
HFO
011
039103
103CL4P
Reducer
12"-HFO-011039103-103CL4P-S
S
155
H
100
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
1"
HFO
011
039103
103CL4P
12"-HFO-011039103-103CL4P-S
011-PI-0092
S
155
H
65
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
1"
HFO
011
039103
103CL4P
12"-HFO-011039103-103CL4P-S
12"-HFO-011039103-103CL4P-S
S
155
H
65
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
12"
HFO
011
039103
103CL4P
SA-JER-DS011-TRJR-480103
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
12"
HFO
011
039103
103CL4P
12"-HFO-011039103-103CL4P-S
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
10"
HFO
011
039103
103CL4P
Reducer
10"-HFO-011039103-103CL4P-S
S
155
H
100
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
10"
HFO
011
039103
103CL4P
Reducer
10"-HFO-011039103-103CL4P-S
S
155
H
100
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
10"
HFO
011
039103
103CL4P
10"-HFO-011039103-103CL4P-S
011-E-0020-A/D
S
155
H
100
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
039103
103CL4P
2"-FLO-011015305-101CS1P-N
10"-HFO-011039103-103CL4P-S
S
155
H
75
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
1"
HFO
011
039103
103CL4P
2"-HFO-011039103-103CL4P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
039103
103CL4P
2"-FLO-011015309-101CS1P-N
10"-HFO-011039103-103CL4P-S
S
155
H
75
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
1"
HFO
011
039103
103CL4P
2"-HFO-011039103-103CL4P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
039103
103CL4P
10"-HFO-011039103-103CL4P-S
Blind flange
S
155
H
75
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
10"
HFO
011
039103
103CL4P
10"-HFO-011039103-103CL4P-S
011-E-0020-D
S
155
H
100
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480029
2"
HFO
011
039103
103CL4P
10"-HFO-011039103-103CL4P-S
Blind flange
S
155
H
75
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
33.10
390.00
-
H
69.95
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
12"
HFO
011
039103
103CL4P
12"-HFO-011039103-103CL4P-S
SA-JER-DS011-TRJR-480029
S
155
H
100
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
12"
HFO
011
039103
103CL4P
12"-HFO-011039103-103CL4P-S
10"-HFO-011039104-103CL4P-S
S
155
H
100
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
1"
HFO
011
039103
103CL4P
12"-HFO-011039103-103CL4P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
10"
HFO
011
039104
103CL4P
12"-HFO-011039103-103CL4P-S
SA-JER-DS011-TRJR-480066
S
155
H
100
VACUUM RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
2"
HFO
011
039104
103CL4P
2"-FLO-011039309-101CS1P-N
10"-HFO-011039104-103CL4P-S
S
155
H
75
VACUUM RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
1"
HFO
011
039104
103CL4P
2"-HFO-011039104-103CL4P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480066
10"
HFO
011
039104
103CL4P
SA-JER-DS011-TRJR-480103
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480066
6"
HFO
011
039104
103CL4P
Reducer
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480066
10"
HFO
011
039104
103CL4P
Reducer
12"-HFO-011027103-103CL4P-S
S
155
H
100
VACUUM RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
2"
HFO
011
039105
101CL4P
Reducer
SA-JER-DS011-TRJR-480081
S
155
H
75
VACUUM RESIDUE
Gas
-
-0.24
360.00
-
-
4.00
-1.00
390.00
390.00
-
H
8.45
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
1"
HFO
011
039105
101CL4P
011-G-0018-A
Reducer
S
155
H
65
VACUUM RESIDUE
Gas
-
-0.24
360.00
-
-
4.00
-1.00
390.00
390.00
-
H
8.45
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
2"
HFO
011
039105
101CL4P
Reducer
2"-HFO-011039105-101CL4P-S
S
155
H
75
VACUUM RESIDUE
Gas
-
-0.24
360.00
-
-
4.00
-1.00
390.00
390.00
-
H
8.45
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480081
2"
HFO
011
039105
101CL4P
SA-JER-DS011-TRJR-480103
011-C-0003
S
155
H
75
VACUUM RESIDUE
Gas
-
-0.24
360.00
-
-
4.00
-1.00
390.00
390.00
-
H
8.45
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
1"
HFO
011
039105
101CL4P
011-G-0018-B
Reducer
S
155
H
65
VACUUM RESIDUE
Gas
-
-0.24
360.00
-
-
4.00
-1.00
390.00
390.00
-
H
8.45
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
10"
HFO
011
039106
103CL4P
011-G-0018-B
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
12"
HFO
011
039106
103CL4P
Reducer
12"-HFO-011039106-103CL4P-S
S
155
H
100
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
1"
HFO
011
039106
103CL4P
12"-HFO-011039106-103CL4P-S
12"-HFO-011039106-103CL4P-S
S
155
H
65
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
1"
HFO
011
039106
103CL4P
12"-HFO-011039106-103CL4P-S
011-PI-0093
S
155
H
65
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-380001
Page 96 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480103
12"
HFO
011
039106
103CL4P
12"-HFO-011039106-103CL4P-S
12"-HFO-011039103-103CL4P-S
S
155
H
100
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
2"
HFO
011
039107
103CL4P
12"-HFO-011039103-103CL4P-S
2"-CLD-011039306-101CH2S-P
S
155
H
75
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
1"
HFO
011
039107
103CL4P
011-G-0018-A
2"-HFO-011039107-103CL4P-S
S
155
H
65
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
3/4"
HFO
011
039107
103CL4P
2"-HFO-011039107-103CL4P-S
1"-OLW-011039004-101CS1P-N
S
155
H
65
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
2"
HFO
011
039107
103CL4P
12"-HFO-011039101-103CL4P-S
2"-HFO-011039107-103CL4P-S
S
155
H
75
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
3/4"
HFO
011
039107
103CL4P
16"-HFO-011039101-103CL4P-S
2"-HFO-011039107-103CL4P-S
S
155
H
65
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
2"
HFO
011
039108
103CL4P
12"-HFO-011039106-103CL4P-S
2"-CLD-011039307-101CH2S-P
S
155
H
75
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
3/4"
HFO
011
039108
103CL4P
2"-HFO-011039108-103CL4P-S
1"-OLW-011039005-101CS1P-N
S
155
H
65
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
1"
HFO
011
039108
103CL4P
011-G-0018-B
2"-HFO-011039108-103CL4P-S
S
155
H
65
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
2"
HFO
011
039108
103CL4P
12"-HFO-011039102-103CL4P-S
2"-HFO-011039108-103CL4P-S
S
155
H
75
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
3/4"
HFO
011
039108
103CL4P
16"-HFO-011039102-103CL4P-S
2"-HFO-011039108-103CL4P-S
S
155
H
65
VACUUM RESIDUE
Liquid
880
17.50
360.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
4"
HFO
011
039109
103CL4P
10"-HFO-011039104-103CL4P-S
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
2"
HFO
011
039109
103CL4P
Reducer
2"-HFO-011039110-103CS1P-S
S
155
H
75
VACUUM RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
4"
HFO
011
039109
103CL4P
4"-HFO-011039109-103CL4P-S
Reducer
S
155
H
100
VACUUM RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
2"
HFO
011
039109
103CL4P
Reducer
Reducer
S
155
H
75
VACUUM RESIDUE
Liquid
880
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
4"
HFO
011
039109
103CL4P
Reducer
4"-HFO-011039110-103CS1P-S
S
155
H
100
VACUUM RESIDUE
Liquid
880
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
4"
HFO
011
039110
103CS1P
4"-HFO-011039109-103CL4P-S
SA-JER-DS011-TRJR-480136
S
155
H
40
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6. STEAN TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
4"
HFO
011
039110
103CS1P
Reducer
4"-HFO-011039110-103CS1P-S
S
155
H
40
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6. STEAN TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
2"
HFO
011
039110
103CS1P
2"-HFO-011039109-103CL4P-S
Reducer
S
155
H
25
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6. STEAN TRACING WITH MPS.
SA-JER-DS011-TRJR-480136
4"
HFO
011
039110
103CS1P
SA-JER-DS011-TRJR-480103
4"-HFO-011039110-103CS1P-S
S
155
H
40
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480136
4"
HFO
011
039110
103CS1P
4"-HFO-011039110-103CS1P-S
16"-SLP-011099001-103CS1P-S
S
41
H
40
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480103
1"
HFO
011
039111
103CL4P
4"-HFO-011039109-103CL4P-S
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
1"-HFO-011039111-103CL4P-S
Blind flange
S
155
H
65
VACUUM RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
2"
HFO
011
039111
103CL4P
Reducer
2"-CLD-011039308-101CH2S-P
S
155
H
75
VACUUM RESIDUE
Liquid
806
14.90
354.00
-
-
28.00
390.00
-
H
59.17
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
3/4"
HFO
011
039111
103CL4P
4"-HFO-011039109-103CL4P-S
1"-HFO-011039111-103CL4P-S
S
155
H
65
VACUUM RESIDUE
Liquid
880
14.90
354.00
-
-
28.00
390.00
-
-
-
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480102
-
HFO
011
039610
103SD0P
011-S-0002
TRIM
S
31
H
-
-
-
-
3.20
322.00
-
-
30.00
355.00
-
Visual Test
0.00
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150 ºC
SA-JER-DS011-TRJR-480102
2"
HFO
011
039610
103SD0P
011-S-0002
Blind flange
S
31
H
65
-
Liquid
775
3.20
322.00
-
-
30.00
355.00
-
H
54.44
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150 ºC
SA-JER-DS011-TRJR-480102
6"
HFO
011
039610
103SD0P
011-S-0002
011-S-0002
S
31
H
100
-
Liquid
775
3.20
322.00
-
-
30.00
355.00
-
H
54.44
NFS
NO
NO
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150 ºC
SA-JER-DS011-TRJR-480019
3/4"
HFO
011
040014
103CS1P
10"-HFO-011010103-103CS1P-S
SA-JER-DS011-TRJR-480104
S
155
H
40
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040014
103CS1P
SA-JER-DS011-TRJR-480019
011-SC-0023
S
155
H
40
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
10"
HFO
011
040101
103CS1P
10"-HFO-011010103-103CS1P-S
011-E-0031-A
S
155
H
65
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
2"
HFO
011
040101
103CS1P
10"-HFO-011040101-103CS1P-S
Blind flange
S
155
H
50
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
2"
HFO
011
040101
103CS1P
2"-FLO-011040302-101CS1P-N
10"-HFO-011040101-103CS1P-S
S
155
H
50
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040101
103CS1P
2"-HFO-011040101-103CS1P-S
Plug
S
155
H
40
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
10"
HFO
011
040102
103CS1P
10"-HFO-011040101-103CS1P-S 10"-HFO-011040103-103CS1P-S
S
155
H
65
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040102
103CS1P
2"-HFO-011040102-103CS1P-S
Plug
S
155
H
40
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480103
1"
HFO
011
039111
103CL4P
SA-JER-DS011-TRJR-480104
2"
HFO
011
040102
103CS1P
2"-FLO-011040301-101CS1P-N
10"-HFO-011040102-103CS1P-S
S
155
H
50
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
10"
HFO
011
040103
103CS1P
011-E-0031-A
011-E-0031-B
S
155
H
65
VACUUM RESIDUE
Liquid
962.56
13.80
191.00
-
-
28.00
311.00
-
H
48.19
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
2"
HFO
011
040103
103CS1P
10"-HFO-011040103-103CS1P-S
Blind flange
S
155
H
50
VACUUM RESIDUE
Liquid
962.56
13.80
191.00
-
-
28.00
311.00
-
H
48.19
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
2"
HFO
011
040103
103CS1P
2"-FLO-011040304-101CS1P-N
10"-HFO-011040103-103CS1P-S
S
155
H
50
VACUUM RESIDUE
Liquid
962.56
13.80
191.00
-
-
28.00
311.00
-
H
48.19
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040103
103CS1P
2"-HFO-011040103-103CS1P-S
Plug
S
155
H
40
VACUUM RESIDUE
Liquid
962.56
13.80
191.00
-
-
28.00
311.00
-
H
48.19
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
10"
HFO
011
040104
103CS1P
10"-HFO-011040103-103CS1P-S 10"-HFO-011040104-103CS1P-S
S
155
H
65
VACUUM RESIDUE
Liquid
962.56
13.80
191.00
-
-
28.00
311.00
-
H
48.19
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
10"
HFO
011
040104
103CS1P
10"-HFO-011040104-103CS1P-S 10"-HFO-011040104-103CS1P-S
S
155
H
65
VACUUM RESIDUE
Liquid
962.56
13.80
191.00
-
-
28.00
311.00
-
H
48.19
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
10"
HFO
011
040104
103CS1P
10"-HFO-011040104-103CS1P-S 12"-HFO-011040106-103CS1P-S
S
155
H
65
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
10"
HFO
011
040104
103CS1P
10"-HFO-011040104-103CS1P-S 10"-HFO-011040104-103CS1P-S
S
155
H
65
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
10"
HFO
011
040105
103CS1P
10"-HFO-011040103-103CS1P-S 12"-HFO-011040106-103CS1P-S
S
155
H
65
VACUUM RESIDUE
Liquid
962.56
13.80
191.00
-
-
28.00
311.00
-
H
48.19
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040105
103CS1P
2"-HFO-011040105-103CS1P-S
Plug
S
155
H
40
VACUUM RESIDUE
Liquid
962.56
13.80
191.00
-
-
28.00
311.00
-
H
48.19
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
2"
HFO
011
040105
103CS1P
2"-FLO-011040303-101CS1P-N
10"-HFO-011040105-103CS1P-S
S
155
H
50
VACUUM RESIDUE
Liquid
962.56
13.80
191.00
-
-
28.00
311.00
-
H
48.19
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
12"
HFO
011
040106
103CS1P
Reducer
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
12"
HFO
011
040106
103CS1P
12"-HFO-011038023-103CS1P-S 12"-HFO-011040106-103CS1P-S
S
155
H
65
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
12"-HFO-011040106-103CS1P-S
SA-JER-DS011-TRJR-480104
2"
HFO
011
040106
103CS1P
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040106
103CS1P
011-TT-0177
S
155
H
50
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
12"-HFO-011040106-103CS1P-S
Plug
S
155
H
40
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480104
2"
HFO
011
040106
103CS1P
NOTE 6. STEAM TRACING WITH MPS.
12"-HFO-011040106-103CS1P-S
011-TT-0175
S
155
H
50
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480104
8"
HFO
011
040106
NOTE 6. STEAM TRACING WITH MPS.
103CS1P
Reducer
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480104
8"
HFO
011
NOTE 6. STEAM TRACING WITH MPS.
040106
103CS1P
Reducer
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480104
12"
HFO
NOTE 6. STEAM TRACING WITH MPS.
011
040106
103CS1P
Reducer
12"-HFO-011040106-103CS1P-S
S
155
H
65
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480104
12"
NOTE 6. STEAM TRACING WITH MPS.
HFO
011
040106
103CS1P
12"-HFO-011040106-103CS1P-S
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480104
NOTE 6. STEAM TRACING WITH MPS.
12"
HFO
011
040106
103CS1P
Reducer
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
12"
HFO
011
040106
103CS1P
12"-HFO-011040106-103CS1P-S
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
6"
HFO
011
040106
103CS1P
Reducer
6"-HFO-011040106-103CS1P-S
S
155
H
50
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480138
16"
HFO
011
040106
103CS1P
SA-JER-DS011-TRJR-480104
IP-1319-L
S
155
H
100
VACUUM RESIDUE
Liquid
968
7.00
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480138
3/4"
HFO
011
040106
103CS1P
16"-HFO-011040106-103CS1P-S
011-PI-0181
S
155
H
40
VACUUM RESIDUE
Liquid
968
7.00
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480138
2"
HFO
011
040106
103CS1P
16"-HFO-011040106-103CS1P-S
Blind flange
S
155
H
50
VACUUM RESIDUE
Liquid
968
7.00
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480138
10"
HFO
011
040106
103CS1P
16"-HFO-011040106-103CS1P-S 10"-HFO-011099104-103CS1P-S
S
155
H
65
VACUUM RESIDUE
Liquid
968
7.00
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
Reducer
S
155
H
50
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
155
H
65
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
6"
HFO
011
040106
103CS1P
SA-JER-DS011-TRJR-480104
12"
HFO
011
040106
103CS1P
Reducer
12"-HFO-011040106-103CS1P-S
S
VACUUM RESIDUE
Liquid
SA-JER-DS011-TRJR-480104
12"
HFO
011
040106
103CS1P
12"-HFO-011040106-103CS1P-S
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
967.6
7.00
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
6"
HFO
011
040106
103CS1P
6"-HFO-011040106-103CS1P-S
Reducer
S
155
H
50
VACUUM RESIDUE
Liquid
967.6
7.00
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
12"
HFO
011
040106
103CS1P
Reducer
12"-HFO-011040106-103CS1P-S
S
155
H
65
VACUUM RESIDUE
Liquid
967.6
7.00
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
10"
HFO
011
040106
103CS1P
011-E-0031-B
Reducer
S
155
H
65
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
16"
HFO
011
040106
103CS1P
Reducer
SA-JER-DS011-TRJR-480138
S
155
H
100
VACUUM RESIDUE
Liquid
967.6
7.00
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040106
103CS1P
2"-HFO-011040106-103CS1P-S
Plug
S
155
H
40
VACUUM RESIDUE
Liquid
967.6
7.00
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
Reducer
SA-JER-DS011-TRJR-480104
2"
HFO
011
040106
103CS1P
2"-FLO-011040307-101CS1P-N
16"-HFO-011040106-103CS1P-S
S
155
H
50
VACUUM RESIDUE
Liquid
967.6
7.00
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040108
103CS1P
10"-HFO-011040104-103CS1P-S
Reducer
S
155
H
40
VACUUM RESIDUE
Liquid
962.56
13.80
191.00
-
-
28.00
311.00
-
H
48.19
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040108
103CS1P 3/4"-HFO-011040108-103CS1P-S
Plug
S
155
H
40
VACUUM RESIDUE
Liquid
962.56
13.80
191.00
-
-
28.00
311.00
-
H
48.19
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
2"
HFO
011
040108
103CS1P
2"-CLD-011040301-101CH2S-P
S
155
H
50
VACUUM RESIDUE
Liquid
962.56
13.80
191.00
-
-
28.00
311.00
-
H
48.19
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040108
103CS1P
10"-HFO-011040104-103CS1P-S 3/4"-HFO-011040108-103CS1P-S
S
155
H
40
VACUUM RESIDUE
Liquid
962.56
13.80
191.00
-
-
28.00
311.00
-
H
48.19
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040109
103CS1P
12"-HFO-011040106-103CS1P-S
Reducer
S
155
H
40
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040109
103CS1P 3/4"-HFO-011040109-103CS1P-S
Plug
S
155
H
40
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
Reducer
SA-JER-DS011-TRJR-480104
2"
HFO
011
040109
103CS1P
S
155
H
50
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040109
103CS1P
12"-HFO-011040106-103CS1P-S 3/4"-HFO-011040109-103CS1P-S
S
155
H
40
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040110
103CS1P
10"-HFO-011010103-103CS1P-S
Reducer
S
155
H
40
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
235.00
-
H
43.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040110
103CS1P 3/4"-HFO-011040110-103CS1P-S
Plug
S
155
H
40
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
235.00
-
H
43.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
2"
HFO
011
040110
103CS1P
2"-CLD-011040302-101CH2S-P
S
155
H
50
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
235.00
-
H
43.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040110
103CS1P
10"-HFO-011010103-103CS1P-S 3/4"-HFO-011040110-103CS1P-S
S
155
H
40
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
235.00
-
H
43.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
2"
HFO
011
040111
103CS1P
10"-HFO-011040103-103CS1P-S
2"-CLD-011040307-101CH2S-P
S
155
H
50
VACUUM RESIDUE
Liquid
962.56
13.80
191.00
-
-
28.00
311.00
-
H
48.19
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040111
103CS1P
2"-HFO-011040111-103CS1P-S
Plug
S
155
H
40
VACUUM RESIDUE
Liquid
962.56
13.80
191.00
-
-
28.00
311.00
-
H
48.19
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
2"
HFO
011
040112
103CS1P
12"-HFO-011040106-103CS1P-S
2"-CLD-011040308-101CH2S-P
S
155
H
50
VACUUM RESIDUE
Liquid
967
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040112
103CS1P
2"-HFO-011040112-103CS1P-S
Plug
S
155
H
40
VACUUM RESIDUE
Liquid
967
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040113
103CS1P
011-SC-0023
10"-HFO-011010103-103CS1P-S
S
155
H
40
VACUUM RESIDUE
Liquid
956
10.20
205.00
-
-
28.00
235.00
-
H
43.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480273
3/4"
HFO
011
040113
103CS1P 3/4"-HFO-011040114-103CS1P-S
8"-RES-011010003-103CS1P-S
S
41
H
40
VACUUM RESIDUE
Liquid
956
10.20
205.00
-
-
28.00
235.00
-
H
43.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-380001
Reducer
Reducer
2"-CLD-011038304-101CH2S-P
Page 97 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
10"-RES-011010003-103CS1P-S
Reducer
S
41
H
40
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
(NOTE 7) THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. NOTE 6.
SA-JER-DS011-TRJR-480273
3/4"
HFO
011
040114
103CS1P
SA-JER-DS011-TRJR-480273
1/2"
HFO
011
040114
103CS1P
Reducer
SAMPLE COOLER
S
41
H
40
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480104
2"
HFO
011
040115
103CS1P
10"-HFO-011040102-103CS1P-S
2"-CLD-011040310-101CH2S-P
S
155
H
50
VACUUM RESIDUE
Liquid
962.56
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040115
103CS1P
2"-HFO-011040115-103CS1P-S
Plug
S
155
H
40
VACUUM RESIDUE
Liquid
962.56
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
2"
HFO
011
040118
103CS1P
UC
Insul Brk
-
-
P
25
VACUUM RESIDUE
Liquid
962.56
13.80
191.00
-
-
28.00
311.00
-
H
48.19
NFS
By Code
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@ 290 ºC
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040118
103CS1P
2"-HFO-011040118-103CS1P-P
Plug
-
-
P
25
VACUUM RESIDUE
Liquid
962.56
13.80
191.00
-
-
28.00
311.00
-
H
48.19
NFS
By Code
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@ 290 ºC
SA-JER-DS011-TRJR-480104
2"
HFO
011
040118
103CS1P
Insul Brk
10"-HFO-011040103-103CS1P-S
S
155
H
50
VACUUM RESIDUE
Liquid
962.56
13.80
191.00
-
-
28.00
311.00
-
H
48.19
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
2"
HFO
011
040119
103CS1P
UC
Insul Brk
-
-
P
25
VACUUM RESIDUE
Liquid
963
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@ 290 ºC
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040119
103CS1P
2"-HFO-011040119-103CS1P-P
Plug
-
-
P
25
VACUUM RESIDUE
Liquid
963
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@ 290 ºC
SA-JER-DS011-TRJR-480104
2"
HFO
011
040119
103CS1P
Insul Brk
12"-HFO-011040106-103CS1P-S
S
155
H
50
VACUUM RESIDUE
Liquid
963
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
Q
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@ 290 ºC
SA-JER-DS011-TRJR-480104
12"
HFO
011
040120
103CS1P
12"-HFO-011040106-103CS1P-S
SA-JER-DS011-TRJR-480100
S
155
H
65
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040120
103CS1P
12"-HFO-011040120-103CS1P-S
Plug
S
155
H
40
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480100
12"
HFO
011
040120
103CS1P
SA-JER-DS011-TRJR-480104
12"-HFO-011008001-103CS1P-S
S
155
H
65
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480100
3/4"
HFO
011
040120
103CS1P
12"-HFO-011040120-103CS1P-S
Blind flange
S
155
H
40
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480100
2"
HFO
011
040120
103CS1P
2"-FLO-011038307-101CS1P-N
12"-HFO-011040120-103CS1P-S
S
155
H
50
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480100
3/4"
HFO
011
040120
103CS1P
2"-HFO-011040120-103CS1P-S
Blind flange
S
155
H
40
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
2"
HFO
011
040121
103CS1P
12"-HFO-011040120-103CS1P-S
2"-CLD-011040311-101CH2S-P
S
155
H
50
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040121
103CS1P
2"-HFO-011040121-103CS1P-S
Plug
S
155
H
40
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
2"
HFO
011
040121
103CS1P
12"-HFO-011038023-103CS1P-S
2"-HFO-011040121-103CS1P-S
S
155
H
50
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
12"-HFO-011040106-103CS1P-S
2"-HFO-011040121-103CS1P-S
S
155
H
50
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
Plug
S
155
H
40
VACUUM RESIDUE
Liquid
956
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
2"
HFO
011
040121
103CS1P
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040122
103CS1P 3/4"-HFO-011040122-103CS1P-S
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040122
103CS1P
8"-HFO-011040106-103CS1P-S
Reducer
S
155
H
40
VACUUM RESIDUE
Liquid
967.6
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
2"
HFO
011
040122
103CS1P
Reducer
2"-CLD-011040312-101CH2S-P
S
155
H
50
VACUUM RESIDUE
Liquid
956
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040122
103CS1P
8"-HFO-011040106-103CS1P-S
3/4"-HFO-011040122-103CS1P-S
S
155
H
40
VACUUM RESIDUE
Liquid
956
12.30
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040123
103CS1P
8"-HFO-011010103-103CS1P-S
3/4"-HFO-011040123-103CS1P-S
S
155
H
40
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040123
103CS1P
8"-HFO-011010103-103CS1P-S
Reducer
S
155
H
40
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
3/4"
HFO
011
040123
103CS1P 3/4"-HFO-011040123-103CS1P-S
Plug
S
155
H
40
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
2"
HFO
011
040123
103CS1P
Reducer
2"-CLD-011040313-101CH2S-P
S
155
H
50
VACUUM RESIDUE
Liquid
956
15.30
205.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
1"
HFO
011
040124
103CS1P
2"-HFO-011010103-103CS1P-S
011-AT-0015
S
155
H
40
VACUUM RESIDUE
Liquid
956
10.20
205.00
-
-
28.00
235.00
-
H
43.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
1"
HFO
011
040125
103CS1P
011-AT-0015
Reducer
S
155
H
40
VACUUM RESIDUE
Liquid
967.6
7.00
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480104
2"
HFO
011
040125
103CS1P
Reducer
16"-HFO-011040106-103CS1P-S
S
155
H
50
VACUUM RESIDUE
Liquid
967.6
7.00
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480134
14"
HFO
011
098001
103CL2P
DS111-TRJR-480043
SA-JER-DS011-TRJR-480052
-
-
H
100
HAGO
Liquid
683
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
3/4"
HFO
011
098001
103CL2P
14"-HFO-011098001-103CL2P-H
011-PI-0166
-
-
H
65
HAGO
Liquid
683
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
3/4"
HFO
011
098001
103CL2P
14"-HFO-011098001-103CL2P-H
011-PT-0427
-
-
H
65
HAGO
Liquid
683
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
14"
HFO
011
098001
103CL2P
SA-JER-DS011-TRJR-480134
Reducer
-
-
H
100
HAGO
Liquid
683
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
2"
HFO
011
098001
103CL2P
14"-HFO-011098001-103CL2P-H
Blind flange
-
-
H
65
HAGO
Liquid
683
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
2"
HFO
011
098001
103CL2P
14"-HFO-011098001-103CL2P-H
011-TT-0197
-
-
H
65
HAGO
Liquid
683
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
18"
HFO
011
098001
103CL2P
Reducer
011-E-0022
-
-
H
100
HAGO
Liquid
685
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
6"
HFO
011
098005
103CS1P
6"-DIE-011025003-103CS1P-N
SA-JER-DS011-TRJR-480137
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
6"
HFO
011
098005
103CS1P
SA-JER-DS011-TRJR-480132
Insul Brk
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
Insul Brk
12"-HFO-011038004-103CS1P-S
S
31
H
50
HAGO
Liquid
853
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
N
-
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
6"
HFO
011
098005
103CS1P
SA-JER-DS011-TRJR-480132
3/4"
HFO
011
098007
103CS1P
8"-DIE-011098006-103CS1P-N
Reducer
-
HAGO
Liquid
SA-JER-DS011-TRJR-480132
2"
HFO
011
098007
103CS1P
Reducer
2"-CLD-011098319-101CH2S-P
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3/4"
HFO
011
098007
103CS1P
8"-DIE-011098006-103CS1P-N
3/4"-HFO-011098007-103CS1P-N
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3/4"
HFO
011
098007
103CS1P
10"-DIE-011098006-103CS1P-H
Insul Brk
-
-
H
25
HAGO
Liquid
875
7.00
50.00
-
-
28.30
118.00
-
H
42.45
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3/4"
HFO
011
098007
103CS1P
Insul Brk
3/4"-HFO-011098007-103CS1P-N
-
-
N
-
HAGO
Liquid
875
7.00
50.00
-
-
28.30
118.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3/4"
HFO
011
098007
103CS1P
10"-DIE-011098006-103CS1P-H
Insul Brk
-
-
H
25
HAGO
Liquid
875
7.00
50.00
-
-
28.30
118.00
-
H
42.45
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3/4"
HFO
011
098007
103CS1P
Insul Brk
3/4"-HFO-011098007-103CS1P-N
-
-
N
-
HAGO
Liquid
875
7.00
50.00
-
-
28.30
118.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3/4"
HFO
011
098007
103CS1P
8"-DIE-011098006-103CS1P-H
Insul Brk
-
-
H
25
HAGO
Liquid
875
7.00
50.00
-
-
28.30
118.00
-
H
42.45
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3/4"
HFO
011
098007
103CS1P
Insul Brk
3/4"-HFO-011098007-103CS1P-N
-
-
N
-
HAGO
Liquid
875
7.00
50.00
-
-
28.30
118.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3/4"
HFO
011
098008
103CS1P
8"-DIE-011025003-103CS1P-N
Reducer
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
2"
HFO
011
098008
103CS1P
Reducer
2"-CLD-011098302-101CH2S-P
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3/4"
HFO
011
098008
103CS1P
6"-DIE-011025003-103CS1P-N
3/4"-HFO-011098008-103CS1P-N
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3/4"
HFO
011
098008
103CS1P
8"-DIE-011025003-103CS1P-N
3/4"-HFO-011098008-103CS1P-N
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
2"
HFO
011
098009
103CL2P
14"-HFO-011098001-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
665
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
2"
HFO
011
098009
103CL2P
Insul Brk
2"-CLD-011098304-101CH2S-P
-
-
P
50
HAGO
Liquid
665
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
2"
HFO
011
098009
103CL2P
2"-HFO-011098009-103CL2P-P
UC
-
-
P
50
HAGO
Liquid
665
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
2"
HFO
011
098009
103CL2P
Insul Brk
2"-HFO-011098009-103CL2P-P
-
-
P
50
HAGO
Liquid
665
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
2"
HFO
011
098009
103CL2P
14"-HFO-011098001-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
665
10.10
289.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
2"
HFO
011
098010
103CL2P
14"-HFO-011027003-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
2"
HFO
011
098010
103CL2P
Insul Brk
2"-CLD-011098305-101CH2S-P
-
-
P
50
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
2"
HFO
011
098010
103CL2P
2"-HFO-011098010-103CL2P-P
UC
-
-
P
50
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
2"
HFO
011
098010
103CL2P
Insul Brk
2"-HFO-011098010-103CL2P-P
-
-
P
50
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
2"
HFO
011
098010
103CL2P
14"-HFO-011027003-103CL2P-H
Insul Brk
-
-
H
65
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
YES
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
12"
HFO
011
098011
103CL2P
14"-HFO-011027003-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
3/4"
HFO
011
098011
103CL2P
011-PDT-0384
12"-HFO-011098011-103CL2P-H
-
-
H
65
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
12"
HFO
011
098011
103CL2P
12"-HFO-011098011-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
8"
HFO
011
098011
103CL2P
Reducer
8"-HFO-011098011-103CL2P-H
-
-
H
100
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
10"
HFO
011
098011
103CL2P
Reducer
Reducer
-
-
H
100
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
12"
HFO
011
098011
103CL2P
Reducer
12"-HFO-011098011-103CL2P-H
-
-
H
100
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
12"
HFO
011
098011
103CL2P
12"-HFO-011098011-103CL2P-H
14"-HFO-011098001-103CL2P-H
-
-
H
100
HAGO
Liquid
665
10.10
309.00
-
-
18.50
340.00
-
H
33.39
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
3/4"
HFO
011
098011
103CL2P
011-PDT-0384
12"-HFO-011098011-103CL2P-H
-
-
H
65
HAGO
Liquid
665
10.10
309.00
-
-
18.50
340.00
-
H
33.39
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
12"
HFO
011
098011
103CL2P
Reducer
12"-HFO-011098011-103CL2P-H
-
-
H
100
HAGO
Liquid
665
10.10
309.00
-
-
18.50
340.00
-
H
33.39
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
8"
HFO
011
098011
103CL2P
8"-HFO-011098011-103CL2P-H
Reducer
-
-
H
100
HAGO
Liquid
665
10.10
309.00
-
-
18.50
340.00
-
H
33.39
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
6"
HFO
011
098012
103CS1P
6"-HFO-011025002-103CS1P-N
Insul Brk
-
-
H
40
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
6"
HFO
011
098012
103CS1P
Insul Brk
Reducer
S
41
H
40
HAGO
Liquid
853
6.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Reducer
8"-SLP-011098003-103CS1P-S
S
41
H
40
HAGO
Liquid
853
6.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
65
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
8"
HFO
011
098012
103CS1P
SA-JER-DS011-TRJR-480134
3/4"
HFO
011
098013
103CL2P
12"-HFO-011098011-103CL2P-H
Insul Brk
-
HAGO
Liquid
SA-JER-DS011-TRJR-480134
3/4"
HFO
011
098013
103CL2P
Insul Brk
Reducer
-
-
P
40
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
By Code
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
3/4"
HFO
011
098013
103CL2P
3/4"-HFO-011098013-103CL2P-P
Plug
-
-
P
40
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
By Code
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
2"
HFO
011
098013
103CL2P
Reducer
2"-CLD-011098321-101CH2S-P
-
-
P
50
HAGO
Liquid
665
13.20
309.00
-
-
18.50
340.00
-
H
33.39
NFS
By Code
Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3"
HFO
011
098014
103CS1P
8"-DIE-011098006-103CS1P-N
Reducer
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
2"
HFO
011
098014
103CS1P
Reducer
Reducer
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3"
HFO
011
098014
103CS1P
Reducer
3"-HFO-011098014-103CS1P-N
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3"
HFO
011
098014
103CS1P
3"-HFO-011098014-103CS1P-N
8"-DIE-011098006-103CS1P-N
-
-
N
-
HAGO
Liquid
875
7.00
50.00
-
-
28.30
118.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3/4"
HFO
011
098015
103CS1P
3"-HFO-011098014-103CS1P-N
Reducer
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
2"
HFO
011
098015
103CS1P
Reducer
2"-CLD-011098324-101CH2S-P
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
3"
HFO
011
098015
103CS1P
3"-HFO-011098014-103CS1P-N
3/4"-HFO-011098015-103CS1P-N
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
6"
HFO
011
098016
103CS1P
8"-DIE-011098006-103CS1P-N
SA-JER-DS011-TRJR-480136
-
-
N
-
HAGO
Liquid
875
7.00
50.00
-
-
28.30
118.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
6"
HFO
011
098016
103CS1P
SA-JER-DS011-TRJR-480132
6"-HFO-011098016-103CS1P-N
-
-
N
-
HAGO
Liquid
875
7.00
50.00
-
-
28.30
118.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 98 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
TO
TYPE
INSULATION (NOTE 2)
TEMP. (ºC)
TYPE
FLUID
THICKNESS (mm)
PHASE
DOC. No.
DENSITY (kg/m3)
(NOTE 3)
(NOTE 4)
OPERATING CONDITIONS PRESS. (BARG)
TEMP. (ºC)
DESIGN CONDITIONS
ALTERNATE CONDITIONS PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
(ºC)
TEST CONDITIONS
MEDIUM (NOTE 5)
PRESS. (BARG)
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6)
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480136
6"
HFO
011
098016
103CS1P
6"-HFO-011098016-103CS1P-N
6"-HFO-011025002-103CS1P-N
-
-
N
-
HAGO
Liquid
853
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
3/4"
HFO
011
099001
103CS1P
12"-HFO-011038004-103CS1P-S
Reducer
S
31
H
40
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
2"
HFO
011
099001
103CS1P
Reducer
2"-CLD-011099303-101CH2S-P
S
31
H
40
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
3/4"
HFO
011
099001
103CS1P
12"-HFO-011038004-103CS1P-S
2"-HFO-011099001-103CS1P-S
S
31
H
40
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
2"
HFO
011
099001
103CS1P
2"-HFO-011099001-103CS1P-S
Blind flange
S
31
H
40
HVGO
Liquid
857
12.14
160.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480138
3/4"
HFO
011
099002
103CS1P
8"-HFO-011038005-103CS1P-S
Reducer
S
31
H
25
HVGO
Liquid
894
7.00
90.00
-
-
30.00
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480138
3/4"
HFO
011
099002
103CS1P 3/4"-HFO-011099002-103CS1P-S
Blind flange
S
31
H
Liquid
894
7.00
90.00
-
-
30.00
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
25
HVGO
N
POTENTIAL
N
N
N
N
-
NOTE 6.
2"-CLD-011099304-101CH2S-P
S
31
H
25
HVGO
Liquid
894
7.00
90.00
-
-
30.00
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
8"-HFO-011038005-103CS1P-S
3/4"-HFO-011099002-103CS1P-S
S
31
H
25
HVGO
Liquid
894
7.00
90.00
-
-
30.00
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
8"-HFO-011038005-103CS1P-S
8"-HFO-011099003-103CS1P-S
S
31
H
40
HVGO
Liquid
894
7.00
90.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
103CS1P
8"-HFO-011099003-103CS1P-S
SA-JER-DS011-TRJR-480136
S
41
H
40
HVGO
Liquid
894
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
099003
103CS1P
2"-HFO-011099003-103CS1P-S
8"-HFO-011099003-103CS1P-S
S
41
H
25
HVGO
Liquid
894
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
011
099003
103CS1P
2"-HFO-011099003-103CS1P-S
Plug
S
41
H
25
HVGO
Liquid
894
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
HFO
011
099003
103CS1P
2"-FLO-011099303-101CS1P-N
2"-HFO-011099003-103CS1P-S
S
41
H
25
HVGO
Liquid
894
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
8"
HFO
011
099003
103CS1P
SA-JER-DS011-TRJR-480138
16"-SLP-011099001-103CS1P-S
S
41
H
40
HVGO
Liquid
894
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480137
2"
HFO
011
099101
103CS1P
10"-HFO-011010103-103CS1P-S
2"-CLD-011099301-101CH2S-P
S
155
H
50
VACUUM RESIDUE
Liquid
956
10.20
205.00
-
-
28.00
235.00
-
H
43.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480137
2"
HFO
011
099101
103CS1P
2"-HFO-011099101-103CS1P-S
Blind flange
S
155
H
50
VACUUM RESIDUE
Liquid
956
10.20
205.00
-
-
28.00
235.00
-
H
43.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480137
2"
HFO
011
099101
103CS1P
10"-HFO-011010103-103CS1P-S
2"-HFO-011099101-103CS1P-S
S
155
H
50
VACUUM RESIDUE
Liquid
956
10.20
205.00
-
-
28.00
235.00
-
H
43.31
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480138
2"
HFO
011
099102
103CS1P
16"-HFO-011040106-103CS1P-S
2"-CLD-011099302-101CH2S-P
S
155
H
50
VACUUM RESIDUE
Liquid
968
7.00
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480138
2"
HFO
011
099102
103CS1P
2"-HFO-011099102-103CS1P-S
UC
S
155
H
50
VACUUM RESIDUE
Liquid
968
7.00
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480138
2"
HFO
011
099102
103CS1P
16"-HFO-011040106-103CS1P-S
2"-HFO-011099102-103CS1P-S
S
155
H
50
VACUUM RESIDUE
Liquid
968
7.00
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480138
16"
HFO
011
099103
103CS1P
16"-HFO-011040106-103CS1P-S 16"-HFO-011099103-103CS1P-S
S
155
H
100
VACUUM RESIDUE
Liquid
837
7.00
180.00
-
-
28.00
208.00
-
H
42.15
NFS
By Code
N or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480138
16"
HFO
011
099103
103CS1P
16"-HFO-011099103-103CS1P-S
16"-SLP-011099001-103CS1P-S
S
155
H
40
VACUUM RESIDUE
Liquid
837
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480138
2"
HFO
011
099103
103CS1P
2"-FLO-011099302-101CS1P-N
16"-HFO-011099103-103CS1P-S
S
155
H
25
VACUUM RESIDUE
Liquid
837
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480138
3/4"
HFO
011
099103
103CS1P
2"-HFO-011099103-103CS1P-S
Plug
S
155
H
25
VACUUM RESIDUE
Liquid
837
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6. STEAM TRACING WITH MPS.
SA-JER-DS011-TRJR-480138
10"
HFO
011
099104
103CS1P
10"-HFO-011040106-103CS1P-S
Insul Brk
S
155
H
40
VACUUM RESIDUE
Liquid
853
7.00
50.00
-
-
28.30
155.00
-
H
42.45
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480138
10"
HFO
011
099104
103CS1P
Insul Brk
SA-JER-DS011-TRJR-480132
-
-
H
40
VACUUM RESIDUE
Liquid
853
7.00
50.00
-
-
28.30
118.00
-
H
42.45
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480138
3/4"
HFO
011
099104
103CS1P
10"-HFO-011099104-103CS1P-H
Plug
-
-
H
25
VACUUM RESIDUE
Liquid
853
7.00
50.00
-
-
28.30
118.00
-
H
42.45
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480132
10"
HFO
011
099104
103CS1P
SA-JER-DS011-TRJR-480138
10"-DIE-011098006-103CS1P-H
-
-
H
40
HAGO
Liquid
875
7.00
50.00
-
-
28.30
118.00
-
H
42.45
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480138
4"
HFO
011
099104
103CS1P
Insul Brk
10"-HFO-011099104-103CS1P-H
-
-
H
25
VACUUM RESIDUE
Liquid
837
7.00
50.00
-
-
28.30
118.00
-
H
42.45
NFS
By Code
M or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480138
4"
HFO
011
099104
103CS1P
4"-FLO-011099304-101CS1P-N
Insul Brk
-
-
P
25
VACUUM RESIDUE
Liquid
853
7.00
50.00
-
-
28.30
118.00
-
H
42.45
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480138
3/4"
HFO
011
099104
103CS1P
4"-HFO-011099104-103CS1P-P
Plug
-
-
P
25
VACUUM RESIDUE
Liquid
853
7.00
50.00
-
-
28.30
118.00
-
H
42.45
NFS
By Code
M
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
HFO
011
200002
103CL2P
SAMPLE COOLER
Reducer
-
-
N
-
MVGO
Liquid
981
19.60
60.00
-
-
30.00
300.00
-
H
53.31
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
4"
HFO
011
200002
103CL2P
Reducer
Reducer
-
-
N
-
MVGO
Liquid
981
19.60
60.00
-
-
30.00
300.00
-
H
53.31
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
HFO
011
200002
103CL2P
Reducer
SO
-
-
N
-
MVGO
Liquid
981
19.60
60.00
-
-
30.00
300.00
-
H
53.31
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
HFO
011
200003
103CS1P 3/4"-HFO-011025008-103CS1P-N
Reducer
-
-
N
-
HAGO
Liquid
854
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480138
2"
HFO
011
099002
103CS1P
SA-JER-DS011-TRJR-480138
3/4"
HFO
011
099002
103CS1P
SA-JER-DS011-TRJR-480138
8"
HFO
011
099003
103CS1P
SA-JER-DS011-TRJR-480138
8"
HFO
011
099003
SA-JER-DS011-TRJR-480138
2"
HFO
011
SA-JER-DS011-TRJR-480138
3/4"
HFO
SA-JER-DS011-TRJR-480138
2"
SA-JER-DS011-TRJR-480136
Reducer
SA-JER-DS011-TRJR-480274
2"
HFO
011
200003
103CS1P
Reducer
2"-CLD-011200307-101CH2S-P
-
-
N
-
HAGO
Liquid
854
7.53
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
3/4"
HFO
011
200101
103CS1P
SAMPLE COOLER
Reducer
-
-
N
-
VACUUM RESIDUE
Liquid
956
15.30
60.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
4"
HFO
011
200101
103CS1P
Reducer
Reducer
-
-
N
-
VACUUM RESIDUE
Liquid
956
15.30
60.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
3/4"
HFO
011
200101
103CS1P
Reducer
Reducer
-
-
N
-
VACUUM RESIDUE
Liquid
956
15.30
60.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
2"
HFO
011
200101
103CS1P
Reducer
2"-CLD-011200325-101CH2S-N
-
-
N
-
VACUUM RESIDUE
Liquid
956
15.30
60.00
-
-
28.00
-
H
49.31
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
1/2"
HFO
011
200101
103CS1P 3/4"-HFO-011200101-103CS1P-N
Reducer
-
-
N
-
VACUUM RESIDUE
Liquid
956
15.30
60.00
-
-
28.00
340.00
-
H
49.31
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
1/4"
HFO
011
200101
103CS1P
Reducer
SO
-
-
N
-
VACUUM RESIDUE
Liquid
956
15.30
60.00
-
-
28.00
340.00
-
-
-
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
1"
HFO
011
200102
103CL4P
SAMPLE COOLER
Reducer
-
-
N
-
ATM. RESIDUE
Liquid
806
14.90
60.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
4"
HFO
011
200102
103CL4P
Reducer
Reducer
-
-
N
-
ATM. RESIDUE
Liquid
806
14.90
60.00
-
-
21.70
390.00
-
H
45.86
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
3/4"
HFO
011
200102
103CL4P
Reducer
Reducer
-
-
N
-
ATM. RESIDUE
Liquid
806
14.90
60.00
-
-
21.70
390.00
-
-
-
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
2"
HFO
011
200102
103CL4P
Reducer
2"-CLD-011200326-101CH2S-N
-
-
N
-
ATM. RESIDUE
Liquid
806
14.90
60.00
-
-
21.70
-
H
45.86
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
1/2"
HFO
011
200102
103CL4P
3/4"-HFO-011200102-103CL4P-N
Reducer
-
-
N
-
ATM. RESIDUE
Liquid
806
14.90
60.00
-
-
21.70
390.00
-
-
-
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
1/4"
HFO
011
200102
103CL4P
Reducer
SO
-
-
N
-
ATM. RESIDUE
Liquid
806
14.90
60.00
-
-
21.70
390.00
-
-
-
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
HFO
011
200103
103CS1P
SAMPLE COOLER
Reducer
-
-
N
-
HVGO
Liquid
902.5
12.14
60.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
Reducer
Reducer
-
-
N
-
HVGO
Liquid
902.5
12.14
60.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
N
-
902.5
12.14
60.00
-
-
30.00
210.00
-
H
45.25
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-0.50
-0.50
340.00
390.00
120.00
120.00
SA-JER-DS011-TRJR-480274
4"
HFO
011
200103
103CS1P
SA-JER-DS011-TRJR-480274
3/4"
HFO
011
200103
103CS1P
Reducer
SO
-
HVGO
Liquid
SA-JER-DS011-TRJR-480290
2"
HFO
011
230101
101CS1P
Reducer
2"-CLD-011230302-101CH2S-P
-
-
P
25
VACUUM RESIDUE
Liquid
1000
0.50
170.00
-
-
3.50
200.00
-
H
5.25
NFS
By Code
B or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480290
1"
HFO
011
230101
101CS1P
011-AS-0002
Reducer
-
-
P
25
VACUUM RESIDUE
Liquid
1000
0.50
170.00
-
-
3.50
200.00
-
H
5.25
NFS
By Code
B or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480290
3/4"
HFO
011
230101
101CS1P
1"-HFO-011230101-101CS1P-P
3/4"-OLW-011230302-101CS1PN
-
-
P
25
VACUUM RESIDUE
Liquid
956
0.50
170.00
-
-
3.50
200.00
-
H
5.25
NFS
By Code
B or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480030
1"
IAI
011
016301
301CG2P
011-IAD-0003
011-DYV-0003
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480042
1"
IAI
011
017301
301CG2P
011-IAD-0024
011-DYV-0024
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480139
1"
IAI
011
028301
301CG2P
011-IAD-0013
151-DYV-0018
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480213
2"
IAI
011
035301
301CG2P
3"-IAI-011074302-301CG2P-N
SA-JER-DS011-TRJR-480264
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480264
2"
IAI
011
035301
301CG2P
SA-JER-DS011-TRJR-480213
Reducer
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480264
1"
IAI
011
035301
301CG2P
Reducer
Blind flange
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480106
1"
IAI
011
041301
301CG2P
011-IAD-0019
011-ZV-0019
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
1"
IAI
011
047301
301CG2P
011-IAD-0107
011-ZYV-0107
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480120
1"
IAI
011
050301
301CG2P
011-IAD-0108
011-ZYV-0108
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480211
3"
IAI
011
074301
301CG2P
IP-1322
SA-JER-DS011-TRJR-480212
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480211
3"
IAI
011
074301
301CG2P
3"-IAI-011074301-301CG2P-N
1"-IAI-011230306-301CG2P-N
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480212
3"
IAI
011
074301
301CG2P
SA-JER-DS011-TRJR-480211
HEADER
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480212
3"
IAI
011
074301
301CG2P
3"-IAI-011074301-301CG2P-N
1"-IAI-011230309-301CG2P-N
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480211
3"
IAI
011
074301
301CG2P
3"-IAI-011074301-301CG2P-N
1"-IAI-011230304-301CG2P-N
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480212
3"
IAI
011
074302
301CG2P
3"-IAI-011074301-301CG2P-N
SA-JER-DS011-TRJR-480213
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480213
3"
IAI
011
074302
301CG2P
SA-JER-DS011-TRJR-480212
HEADER
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480213
1"
IAI
011
220302
301CG2P
3"-IAI-011074302-301CG2P-N
SA-JER-DS011-TRJR-480030
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480030
1"
IAI
011
220302
301CG2P
SA-JER-DS011-TRJR-480213
011-IAD-0003
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480213
1"
IAI
011
220305
301CG2P
3"-IAI-011074302-301CG2P-N
SA-JER-DS011-TRJR-480139
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480139
1"
IAI
011
220305
301CG2P
SA-JER-DS011-TRJR-480213
011-IAD-0013
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480213
1"
IAI
011
220308
301CG2P
3"-IAI-011074302-301CG2P-N
SA-JER-DS011-TRJR-480117
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
1"
IAI
011
220308
301CG2P
SA-JER-DS011-TRJR-480213
011-IAD-0107
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480213
1"
IAI
011
220309
301CG2P
3"-IAI-011074302-301CG2P-N
SA-JER-DS011-TRJR-480120
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480120
1"
IAI
011
220309
301CG2P
SA-JER-DS011-TRJR-480213
011-IAD-0108
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480213
1"
IAI
011
220310
301CG2P
3"-IAI-011074302-301CG2P-N
SA-JER-DS011-TRJR-480042
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480042
1"
IAI
011
220310
301CG2P
SA-JER-DS011-TRJR-480213
011-IAD-0024
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480213
1"
IAI
011
220311
301CG2P
3"-IAI-011074302-301CG2P-N
SA-JER-DS011-TRJR-480106
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480106
1"
IAI
011
220311
301CG2P
SA-JER-DS011-TRJR-480213
011-IAD-0019
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480211
1"
IAI
011
230301
301CG2P
3"-IAI-011074301-301CG2P-N
SA-JER-DS011-TRJR-480289
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480289
1"
IAI
011
230301
301CG2P
SA-JER-DS011-TRJR-480211
Blind flange
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480211
1"
IAI
011
230302
301CG2P
3"-IAI-011074301-301CG2P-N
SA-JER-DS011-TRJR-480290
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480290
1"
IAI
011
230302
301CG2P
SA-JER-DS011-TRJR-480211
011-AS-0002
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480213
1"
IAI
011
230303
301CG2P
3"-IAI-011074302-301CG2P-N
SA-JER-DS011-TRJR-480291
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480291
1"
IAI
011
230303
301CG2P
SA-JER-DS011-TRJR-480213
011-ALP-0001
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480211
1"
IAI
011
230304
301CG2P
3"-IAI-011074301-301CG2P-N
SA-JER-DS011-TRJR-480255
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480255
1"
IAI
011
230304
301CG2P
011-G-0001-A
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
SA-JER-DS011-TRJR-480211
Page 99 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
-
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480255
1"
IAI
011
230305
301CG2P
1"-IAI-011230304-301CG2P-N
011-G-0001-B
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480211
1"
IAI
011
230306
301CG2P
3"-IAI-011074301-301CG2P-N
SA-JER-DS011-TRJR-480257
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480257
1"
IAI
011
230306
301CG2P
SA-JER-DS011-TRJR-480211
011-G-0002-A
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480257
1"
IAI
011
230307
301CG2P
1"-IAI-011230306-301CG2P-N
011-G-0002-B
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480259
1"
IAI
011
230308
301CG2P
1"-IAI-011230309-301CG2P-N
ELECTRICAL PANEL
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480212
1"
IAI
011
230309
301CG2P
3"-IAI-011074301-301CG2P-N
SA-JER-DS011-TRJR-480259
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480259
1"
IAI
011
230309
301CG2P
SA-JER-DS011-TRJR-480212
ELECTRICAL PANEL
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480261
1"
IAI
011
230310
301CG2P
1"-IAI-011230311-301CG2P-N
011-G-0017-A
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480213
1"
IAI
011
230311
301CG2P
2"-IAI-011403301-301CG2P-N
SA-JER-DS011-TRJR-480261
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480261
1"
IAI
011
230311
301CG2P
SA-JER-DS011-TRJR-480213
011-G-0017-B
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480213
2"
IAI
011
403301
301CG2P
3"-IAI-011074302-301CG2P-N
SA-JER-DS011-TRJR-480270
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480270
2"
IAI
011
403301
301CG2P
SA-JER-DS011-TRJR-480213
Reducer
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480270
1-1/2"
IAI
011
403301
301CG2P
Blind flange
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480270
1-1/2"
IAI
011
403301
301CG2P
SA-JER-DS011-TRJR-480269
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480269
1-1/2"
IAI
011
403301
301CG2P
011-PV-0160-B
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480269
1-1/2"
IAI
011
403301
301CG2P
011-PV-0160-AC
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480269
1-1/2"
IAI
011
403301
301CG2P
011-PV-0160-CC
-
-
N
-
INSTRUMENT AIR
Gas
-
8.00
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480003
8"
JET
011
001001
103CS1P
Reducer 1-1/2"-IAI-011403301-301CG2PN SA-JER-DS011-TRJR-480270 1-1/2"-IAI-011403301-301CG2PN 1-1/2"-IAI-011403301-301CG2PN 011-E-0001
SA-JER-DS011-TRJR-480058
-
-
H
40
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
2"
JET
011
001001
103CS1P
8"-JET-011001001-103CS1P-H
011-TT-0003
-
-
H
25
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
8"
JET
011
001001
103CS1P
SA-JER-DS011-TRJR-480003
011-E-0023
-
-
H
40
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
2"
JET
011
001001
103CS1P
8"-JET-011001001-103CS1P-H
011-AT-0024
-
-
H
25
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
2"
JET
011
001001
103CS1P
8"-JET-011001001-103CS1P-H
011-AT-0022
-
-
H
25
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
2"
JET
011
001001
103CS1P
8"-JET-011001001-103CS1P-H
011-AT-0011
-
-
H
25
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
2"
JET
011
001002
103CS1P
8"-JET-011001001-103CS1P-H
Insul Brk
-
-
H
25
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
2"
JET
011
001002
103CS1P
Insul Brk
2"-CLD-011001310-101CH2S-P
-
-
P
25
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
2"
JET
011
001002
103CS1P
2"-JET-011001002-103CS1P-P
Blind flange
-
-
P
25
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
12"
JET
011
004001
101CS1P
011-E-0007-B
Reducer
-
-
H
50
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
12"
JET
011
004001
101CS1P
011-E-0007-D
Reducer
-
-
H
50
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
16"
JET
011
004001
101CS1P
Reducer
Reducer
-
-
H
65
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
1/2"
JET
011
004001
101CS1P
011-FT-0003
011-FE-0003
-
-
H
25
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
2"
JET
011
004001
101CS1P
16"-JET-011004001-101CS1P-H
011-TT-0024
-
-
H
40
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
1/2"
JET
011
004001
101CS1P
011-FT-0003
011-FE-0003
-
-
H
25
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
3/4"
JET
011
004001
101CS1P
16"-JET-011004001-101CS1P-H
011-PDT-0449
-
-
H
25
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
16"
JET
011
004001
101CS1P
Reducer
16"-JET-011004001-101CS1P-H
-
-
H
65
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
8"
JET
011
004001
101CS1P
Reducer
8"-JET-011004001-101CS1P-H
-
-
H
50
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
14"
JET
011
004001
101CS1P
16"-JET-011004001-101CS1P-H
Reducer
-
-
H
50
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
16"
JET
011
004001
101CS1P
SA-JER-DS011-TRJR-480008
Reducer
-
-
H
65
KERO
Liquid
698.5
5.40
122.00
-
-
7.10
200.00
-
H
10.65
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
16"
JET
011
004001
101CS1P
16"-JET-011004001-101CS1P-H
Reducer
-
-
H
65
KERO
Liquid
698.5
5.40
122.00
-
-
7.10
200.00
-
H
10.65
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
12"
JET
011
004001
101CS1P
Reducer
011-C-0002
-
-
H
50
KERO
Liquid
698.5
5.40
122.00
-
-
7.10
200.00
-
H
10.65
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
12"
JET
011
004001
101CS1P
Reducer
011-C-0002
-
-
H
50
KERO
Liquid
698.5
5.40
122.00
-
-
7.10
200.00
-
H
10.65
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
10"
JET
011
004001
101CS1P
Reducer
Reducer
-
-
H
50
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
16"
JET
011
004001
101CS1P
Reducer
16"-JET-011004001-101CS1P-H
-
-
H
65
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
16"
JET
011
004001
101CS1P
16"-JET-011004001-101CS1P-H
SA-JER-DS011-TRJR-480043
-
-
H
65
KERO
Liquid
698.5
5.40
122.00
-
-
7.10
200.00
-
H
10.65
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
14"
JET
011
004001
101CS1P
Reducer
16"-JET-011004001-101CS1P-H
-
-
H
50
KERO
Liquid
698.5
5.40
122.00
-
-
7.10
200.00
-
H
10.65
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
8"
JET
011
004001
101CS1P
8"-JET-011004001-101CS1P-H
Reducer
-
-
H
50
KERO
Liquid
698.5
5.40
122.00
-
-
7.10
200.00
-
H
10.65
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
10"
JET
011
004002
101CS1P
16"-JET-011026001-101CS1P-H
Reducer
-
-
H
65
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
10"
JET
011
004002
101CS1P
Reducer
10"-JET-011004002-101CS1P-H
-
-
H
65
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
4"
JET
011
004002
101CS1P
4"-JET-011004002-101CS1P-H
Reducer
-
-
H
50
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
6"
JET
011
004002
101CS1P
Reducer
Reducer
-
-
H
50
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
10"
JET
011
004002
101CS1P
Reducer
10"-JET-011004002-101CS1P-H
-
-
H
65
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
10"
JET
011
004002
101CS1P
10"-JET-011004002-101CS1P-H
16"-JET-011004001-101CS1P-H
-
-
H
50
KERO
Liquid
656
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
10"
JET
011
004002
101CS1P
10"-JET-011004002-101CS1P-H
Reducer
-
-
H
50
KERO
Liquid
656
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
4"
JET
011
004002
101CS1P
Reducer
4"-JET-011004002-101CS1P-H
-
-
H
50
KERO
Liquid
656
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
3/4"
JET
011
004003
101CS1P
16"-JET-011004001-101CS1P-H
Insul Brk
-
-
H
25
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
3/4"
JET
011
004003
101CS1P
Insul Brk
Reducer
-
-
P
25
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
3/4"
JET
011
004003
101CS1P
3/4"-JET-011004003-101CS1P-P
Plug
-
-
P
25
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
2"
JET
011
004003
101CS1P
Reducer
2"-CLD-011004302-101CH2S-P
-
-
P
25
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
3/4"
JET
011
004004
101CS1P
10"-JET-011004002-101CS1P-H
Insul Brk
-
-
H
40
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
3/4"
JET
011
004004
101CS1P
Insul Brk
Reducer
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
3/4"
JET
011
004004
101CS1P
3/4"-JET-011004004-101CS1P-P
Plug
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
2"
JET
011
004004
101CS1P
Reducer
2"-CLD-011004301-101CH2S-P
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
3/4"
JET
011
004004
101CS1P
10"-JET-011004002-101CS1P-H
Insul Brk
-
-
H
40
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
3/4"
JET
011
004004
101CS1P
Insul Brk
3/4"-JET-011004004-101CS1P-P
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
2"
JET
011
004005
101CS1P
12"-JET-011004001-101CS1P-H
Insul Brk
-
-
H
40
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
2"
JET
011
004005
101CS1P
Insul Brk
2"-CLD-011004306-101CH2S-P
-
-
P
25
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
2"
JET
011
004005
101CS1P
2"-JET-011004005-101CS1P-P
Blind flange
-
-
P
25
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
2"
JET
011
004006
101CS1P
12"-JET-011004001-101CS1P-H
Insul Brk
-
-
H
40
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
2"
JET
011
004006
101CS1P
Insul Brk
2"-CLD-011004309-101CH2S-P
-
-
P
25
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
2"
JET
011
004006
101CS1P
2"-JET-011004006-101CS1P-P
Blind flange
-
-
P
25
KERO
Liquid
698.5
7.20
122.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
3/4"
JET
011
004007
101CS1P
16"-JET-011026001-101CS1P-H
Insul Brk
-
-
H
40
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
3/4"
JET
011
004007
101CS1P
Insul Brk
Reducer
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
3/4"
JET
011
004007
101CS1P
3/4"-JET-011004007-101CS1P-P
Plug
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480008
2"
JET
011
004007
101CS1P
Reducer
2"-CLD-011004311-101CH2S-P
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
2"
JET
011
004008
101CS1P
UC
Insul Brk
-
-
P
25
FRESH CRUDE
Liquid
847
7.46
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@290ºC.
SA-JER-DS011-TRJR-480008
3/4"
JET
011
004008
101CS1P
2"-JET-011004008-101CS1P-P
Blind flange
-
-
P
25
FRESH CRUDE
Liquid
847
7.46
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@290ºC.
SA-JER-DS011-TRJR-480008
2"
JET
011
004008
101CS1P
Insul Brk
16"-JET-011026001-101CS1P-H
-
-
H
40
FRESH CRUDE
Liquid
847
7.46
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@290ºC.
Y
POTENTIAL
N
N
N
N
-
NOTE 6
NOTE 6
if insulated N or Q SA-JER-DS011-TRJR-480008
-
JET
011
004601
103CS1P
011-E-0007
TRIM
-
-
H
-
-
-
-
7.80
171.00
-
-
38.50
200.00
-
Visual Test
0.00
NFS
By Code
SA-JER-DS011-TRJR-480009
8"
JET
011
005001
SA-JER-DS011-TRJR-480009
2"
JET
011
005001
103CS1P
011-E-0008
SA-JER-DS011-TRJR-480003
-
-
H
50
KERO
Liquid
690
11.20
145.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
103CS1P
8"-JET-011005001-103CS1P-H
011-TT-0028
-
-
H
40
KERO
Liquid
690
11.20
145.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480003
8"
JET
011
NOTE 6
005001
103CS1P
SA-JER-DS011-TRJR-480009
011-E-0001
-
-
H
50
KERO
Liquid
690
11.20
145.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480003
1/2"
JET
SA-JER-DS011-TRJR-480003
1/2"
JET
NOTE 6
011
005001
103CS1P
011-FE-0139
011-FT-0139
-
-
H
25
KERO
Liquid
690
11.20
145.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
011
005001
103CS1P
011-FE-0139
011-FT-0139
-
-
H
25
KERO
Liquid
690
11.20
145.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480009
2"
NOTE 6
JET
011
005002
103CS1P
8"-JET-011005001-103CS1P-H
Insul Brk
-
-
H
40
KERO
Liquid
690
11.20
145.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480009
2"
JET
011
005002
103CS1P
Insul Brk
2"-CLD-011005308-101CH2S-P
-
-
P
25
KERO
Liquid
690
11.20
145.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480009
2"
JET
011
005002
103CS1P
2"-JET-011005002-103CS1P-P
Blind flange
-
-
P
25
KERO
Liquid
690
11.20
145.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
24"
JET
011
018001
101CS1P
011-C-0002
Reducer
-
-
H
100
KERO
Liquid
657
1.00
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
24"
JET
011
018001
101CS1P
011-C-0002
Reducer
-
-
H
100
KERO
Liquid
657
1.00
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
28"
JET
011
018001
101CS1P
Reducer
011-ZV-0077
-
-
H
100
KERO
Liquid
657
1.00
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
if NOT insulated B or Q
NOTE 6
Page 100 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
INSULATION (NOTE 2)
TYPE
FLUID
THICKNESS (mm)
PHASE
(NOTE 3)
DOC. No.
DENSITY (kg/m3)
(NOTE 4)
OPERATING CONDITIONS PRESS. (BARG)
TEMP. (ºC)
DESIGN CONDITIONS
ALTERNATE CONDITIONS PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
(ºC)
TEST CONDITIONS
MEDIUM (NOTE 5)
PRESS. (BARG)
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6)
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480043
28"
JET
011
018001
101CS1P
Reducer
28"-JET-011018001-101CS1P-H
-
-
H
100
KERO
Liquid
657
1.00
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
28"
JET
011
018001
101CS1P
011-ZV-0077
SA-JER-DS011-TRJR-480052
-
-
H
100
KERO
Liquid
657
4.60
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
2"
JET
011
018001
101CS1P
28"-JET-011018001-101CS1P-H
Blind flange
-
-
H
40
KERO
Liquid
657
4.60
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
28"
JET
011
018001
101CS1P
SA-JER-DS011-TRJR-480043
Reducer
-
-
H
100
KERO
Liquid
657
4.60
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
24"
JET
011
018001
101CS1P
Reducer
SA-JER-DS011-TRJR-480063
-
-
H
100
KERO
Liquid
657
4.60
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
24"
JET
011
018001
101CS1P
SA-JER-DS011-TRJR-480052
Reducer
-
-
H
100
KERO
Liquid
657
4.60
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
18"
JET
011
018001
101CS1P
Reducer
18"-JET-011026003-101CS1P-H
-
-
H
65
KERO
Liquid
657
4.60
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
24"
JET
011
018001
101CS1P
24"-JET-011018001-101CS1P-H
Reducer
-
-
H
100
KERO
Liquid
657
4.60
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
18"
JET
011
018001
101CS1P
Reducer
18"-JET-011026004-101CS1P-H
-
-
H
65
KERO
Liquid
657
4.60
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
3/4"
JET
011
018002
101CS1P
8"-JET-011026002-101CS1P-H
Insul Brk
-
-
H
40
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
3/4"
JET
011
018002
101CS1P
Insul Brk
Reducer
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
3/4"
JET
011
018002
101CS1P
3/4"-JET-011018002-101CS1P-P
Plug
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
2"
JET
011
018002
101CS1P
Reducer
2"-CLD-011018308-101CH2S-P
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
3/4"
JET
011
018002
101CS1P
8"-JET-011026002-101CS1P-H
Insul Brk
-
-
H
40
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
3/4"
JET
011
018002
101CS1P
Insul Brk
3/4"-JET-011018002-101CS1P-P
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
3/4"
JET
011
018003
101CS1P
011-LG-0011
Reducer
-
-
P
25
KERO
Liquid
656
1.25
171.00
-
-
6.50
200.00
-
H
9.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
3/4"
JET
011
018003
101CS1P
3/4"-JET-011018003-101CS1P-P
Plug
-
-
P
25
KERO
Liquid
656
1.25
171.00
-
-
6.50
200.00
-
H
9.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
2"
JET
011
018003
101CS1P
Reducer
2"-CLD-011018315-101CH2S-P
-
-
P
25
KERO
Liquid
656
1.25
171.00
-
-
6.50
200.00
-
H
9.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
3/4"
JET
011
018301
101CS1P
011-LG-0011
3/4"-LFL-011018302-101CH2F-N
-
-
P
25
KERO
Gas
-
1.25
203.00
-
-
3.50
280.00
-
H
5.73
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
3/4"
JET
011
018301
101CS1P
3/4"-JET-011018301-101CS1P-P
Blind flange
-
-
P
25
KERO
Gas
-
1.25
203.00
-
-
3.50
280.00
-
H
5.73
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200°C
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200°C
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200°C
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200°C
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200°C
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200°C
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200°C
if insulated N or Q SA-JER-DS011-TRJR-480043
-
JET
011
018601
103CS1P
011-C-0002
TRIM
-
-
H
-
-
-
-
1.60
360.00
-
-
4.10
390.00
-
Visual Test
0.00
NFS
By Code
SA-JER-DS011-TRJR-480043
2"
JET
011
018601
103CS1P
011-C-0002
011-LT-0012
-
-
H
75
-
-
-
1.60
360.00
-
-
4.10
390.00
-
H
8.71
NFS
By Code
SA-JER-DS011-TRJR-480043
2"
JET
011
018601
103CS1P
011-C-0002
011-LG-0011
-
-
H
75
-
-
-
1.60
360.00
-
-
4.10
390.00
-
H
8.71
NFS
By Code
SA-JER-DS011-TRJR-480043
2"
JET
011
018601
103CS1P
011-C-0002
011-LT-0012
-
-
H
75
-
-
-
1.60
360.00
-
-
4.10
390.00
-
H
8.71
NFS
By Code
SA-JER-DS011-TRJR-480043
2"
JET
011
018601
103CS1P
011-C-0002
011-LT-0010
-
-
H
75
-
-
-
1.60
360.00
-
-
4.10
390.00
-
H
8.71
NFS
By Code
SA-JER-DS011-TRJR-480043
2"
JET
011
018601
103CS1P
011-C-0002
011-LG-0011
-
-
H
75
-
-
-
1.60
360.00
-
-
4.10
390.00
-
H
8.71
NFS
By Code
SA-JER-DS011-TRJR-480043
2"
JET
011
018601
103CS1P
011-C-0002
011-LT-0010
-
-
H
75
-
-
-
1.60
360.00
-
-
4.10
390.00
-
H
8.71
NFS
By Code
SA-JER-DS011-TRJR-480052
12"
JET
011
022001
101CS1P
28"-JET-011018001-101CS1P-H
Reducer
-
-
H
65
KERO
Liquid
657
4.60
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
10"
JET
011
022001
101CS1P
Reducer
12"-JET-011022001-101CS1P-H
-
-
H
65
KERO
Liquid
657
4.60
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
6"
JET
011
022001
101CS1P
6"-JET-011022001-101CS1P-H
Reducer
-
-
H
50
KERO
Liquid
657
4.60
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
6"
JET
011
022001
101CS1P
Reducer
Reducer
-
-
H
50
KERO
Liquid
657
4.60
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
12"
JET
011
022001
101CS1P
Reducer
12"-JET-011022001-101CS1P-H
-
-
H
65
KERO
Liquid
657
4.60
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
12"
JET
011
022001
101CS1P
12"-JET-011022001-101CS1P-H
011-C-0004
-
-
H
65
KERO
Liquid
657
1.25
171.00
-
-
3.70
220.00
-
H
5.64
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
10"
JET
011
022001
101CS1P
12"-JET-011022001-101CS1P-H
Reducer
-
-
H
65
KERO
Liquid
657
1.25
171.00
-
-
3.70
220.00
-
H
5.64
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
6"
JET
011
022001
101CS1P
Reducer
6"-JET-011022001-101CS1P-H
-
-
H
50
KERO
Liquid
657
1.25
171.00
-
-
3.70
220.00
-
H
5.64
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
16"
JET
011
022002
101CS1P
011-C-0004
SA-JER-DS011-TRJR-480043
-
-
H
100
KERO
Gas
-
1.10
187.00
-
-
3.70
220.00
-
H
5.64
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
2"
JET
011
022002
101CS1P
16"-JET-011022002-101CS1P-H
011-TT-0120
-
-
H
50
KERO
Gas
-
1.10
187.00
-
-
3.70
220.00
-
H
5.64
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
3/4"
JET
011
022002
101CS1P
16"-JET-011022002-101CS1P-H
011-PI-0044
-
-
H
40
KERO
Gas
-
1.10
187.00
-
-
3.70
220.00
-
H
5.64
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
16"
JET
011
022002
101CS1P
SA-JER-DS011-TRJR-480052
011-C-0002
-
-
H
100
KERO
Gas
-
1.10
187.00
-
-
3.70
220.00
-
H
5.64
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
12"
JET
011
022003
103CS1P
011-ZV-0011
SA-JER-DS011-TRJR-480053
-
-
H
100
KERO
Liquid
624
1.20
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
2"
JET
011
022003
103CS1P
12"-JET-011022003-103CS1P-H
011-TT-0123
-
-
H
50
KERO
Liquid
624
1.20
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480053
12"
JET
011
022003
103CS1P
SA-JER-DS011-TRJR-480052
12"-JET-011022004-103CS1P-H
-
-
H
100
KERO
Liquid
624
1.20
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480053
12"
JET
011
022003
103CS1P
12"-JET-011022004-103CS1P-H
12"-JET-011022005-103CS1P-H
-
-
H
100
KERO
Liquid
624
1.20
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480053
12"
JET
011
022004
103CS1P
12"-JET-011022004-103CS1P-H
Reducer
-
-
H
100
KERO
Liquid
624
1.20
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
3/4"
JET
011
022004
103CS1P
12"-JET-011022004-103CS1P-H
011-PI-0203
-
-
H
40
KERO
Liquid
624
1.20
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
2"
JET
011
022004
103CS1P
12"-JET-011022004-103CS1P-H
UC
-
-
H
50
KERO
Liquid
624
1.20
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480053
8"
JET
011
022004
103CS1P
Reducer
011-G-0009-A
-
-
H
65
KERO
Liquid
624
1.20
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
12"
JET
011
022004
103CS1P
12"-JET-011022003-103CS1P-H
12"-JET-011022004-103CS1P-H
-
-
H
100
KERO
Liquid
624
1.20
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480053
12"
JET
011
022005
103CS1P
12"-JET-011022003-103CS1P-H
Reducer
-
-
H
100
KERO
Liquid
624
1.20
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
3/4"
JET
011
022005
103CS1P
12"-JET-011022005-103CS1P-H
011-PI-0209
-
-
H
40
KERO
Liquid
624
1.20
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
2"
JET
011
022005
103CS1P
12"-JET-011022005-103CS1P-H
UC
-
-
H
50
KERO
Liquid
624
1.20
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
8"
JET
011
022005
103CS1P
Reducer
011-G-0009-B
-
-
H
65
KERO
Liquid
624
1.20
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
4"
JET
011
022006
103CS1P
011-G-0009-A
Reducer
-
-
H
65
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
-
if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q
-
SA-JER-DS011-TRJR-480053
8"
JET
011
022006
103CS1P
Reducer
8"-JET-011022006-103CS1P-H
-
-
H
65
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
3/4"
JET
011
022006
103CS1P
8"-JET-011022006-103CS1P-H
011-PI-0047
-
-
H
40
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
3/4"
JET
011
022006
103CS1P
8"-JET-011022006-103CS1P-H
8"-JET-011022006-103CS1P-H
-
-
H
40
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480009
8"
JET
011
022006
103CS1P
SA-JER-DS011-TRJR-480053
011-E-0008
-
-
H
65
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480009
2"
JET
011
022006
103CS1P
8"-JET-011022006-103CS1P-H
011-TT-0207
-
-
H
50
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480053
8"
JET
011
022006
103CS1P
8"-JET-011022006-103CS1P-H
SA-JER-DS011-TRJR-480009
-
-
H
65
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
20"
JET
011
022007
101CS1P
011-C-0004
HEADER
-
-
H
100
KERO
Liquid
624
1.20
205.00
-
-
3.70
-1.00
250.00
250.00
-
H
5.81
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
2"
JET
011
022007
101CS1P
20"-JET-011022007-101CS1P-H
011-TT-0122
-
-
H
50
KERO
Liquid
624
1.20
205.00
-
-
3.70
-1.00
250.00
250.00
-
H
5.81
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
20"
JET
011
022007
101CS1P
20"-JET-011022007-101CS1P-H
HEADER
-
-
H
100
KERO
Liquid
624
1.20
205.00
-
-
3.70
-1.00
250.00
250.00
-
H
5.81
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
16"
JET
011
022007
101CS1P
011-E-0022
20"-JET-011022007-101CS1P-H
-
-
H
100
KERO
Liquid
624
1.20
205.00
-
-
3.70
-1.00
250.00
250.00
-
H
5.81
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
16"
JET
011
022007
101CS1P
20"-JET-011022007-101CS1P-H
011-E-0022
-
-
H
100
KERO
Liquid
624
1.20
205.00
-
-
3.70
-1.00
250.00
250.00
-
H
5.81
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
20"
JET
011
022008
101CS1P
011-E-0022
28"-JET-011022008-101CS1P-H
-
-
H
100
KERO
Liquid/Gas Mixture
17.5
1.10
214.00
-
-
3.70
-1.00
250.00
250.00
-
H
5.81
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6. NOTE 7
SA-JER-DS011-TRJR-480052
20"
JET
011
022008
101CS1P
011-E-0022
28"-JET-011022008-101CS1P-H
-
-
H
100
KERO
Liquid/Gas Mixture
17.5
1.10
214.00
-
-
3.70
-1.00
250.00
250.00
-
H
5.81
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6. NOTE 7
SA-JER-DS011-TRJR-480052
28"
JET
011
022008
101CS1P
HEADER
011-C-0004
-
-
H
100
KERO
Liquid/Gas Mixture
17.5
1.10
214.00
-
-
3.70
-1.00
250.00
250.00
-
H
5.81
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6. NOTE 7
SA-JER-DS011-TRJR-480052
2"
JET
011
022008
101CS1P
28"-JET-011022008-101CS1P-H
011-TT-0121
-
-
H
50
KERO
Liquid/Gas Mixture
17.5
1.10
214.00
-
-
3.70
-1.00
250.00
250.00
-
H
5.81
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6. NOTE 7
SA-JER-DS011-TRJR-480052
28"
JET
011
022008
101CS1P
HEADER
28"-JET-011022008-101CS1P-H
-
-
H
100
KERO
Liquid/Gas Mixture
17.5
1.10
214.00
-
-
3.70
-1.00
250.00
250.00
-
H
5.81
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6. NOTE 7
SA-JER-DS011-TRJR-480052
2"
JET
011
022008
101CS1P
28"-JET-011022008-101CS1P-H
Blind flange
-
-
H
50
KERO
Liquid/Gas Mixture
17.5
1.10
214.00
-
-
3.70
-1.00
250.00
250.00
-
H
5.81
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6. NOTE 7
SA-JER-DS011-TRJR-480052
3/4"
JET
011
022010
101CS1P
12"-JET-011022001-101CS1P-H
Insul Brk
-
-
H
40
KERO
Liquid
657
4.60
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
3/4"
JET
011
022010
101CS1P
Insul Brk
Reducer
-
-
P
25
KERO
Liquid
657
4.60
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
Page 101 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9) JET
UNIT
NUMBER
LINE CLASS
FROM
011
022010
101CS1P
TO
TYPE -
TEMP. (ºC) -
INSULATION (NOTE 2)
TYPE P
FLUID
THICKNESS (mm) 25
PHASE
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
Liquid
657
4.60
171.00
-
-
PRESS. (BARG)
TEMP. (ºC)
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
-
H
10.50
NFS
05 14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
3/4"-JET-011022010-101CS1P-P
Plug
Y
POTENTIAL
N
N
N
N
-
-
2"
JET
011
022010
101CS1P
Reducer
2"-CLD-011022305-101CH2S-P
-
-
P
25
KERO
Liquid
657
4.60
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
3/4"
JET
011
022010
101CS1P
12"-JET-011022001-101CS1P-H
Insul Brk
-
-
H
40
KERO
Liquid
657
4.60
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
3/4"
JET
011
022010
101CS1P
Insul Brk
3/4"-JET-011022010-101CS1P-P
-
-
P
25
KERO
Liquid
657
4.60
171.00
-
-
7.00
200.00
-
H
10.50
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
3/4"
JET
011
022011
103CS1P
011-LG-0035-A
Reducer
-
-
P
25
KERO
Liquid
624
1.20
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
2"
JET
011
022011
103CS1P
Reducer
2"-CLD-011022301-101CH2S-P
-
-
P
40
KERO
Liquid
624
1.20
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
-
-
P
25
KERO
Liquid
624
1.20
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
250.00
-
H
28.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
-
H
5.81
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
3/4"
JET
011
022011
103CS1P
3/4"-JET-011022011-103CS1P-P
3/4"-OLW-011022001-101CS1PN
SA-JER-DS011-TRJR-480052
3/4"
JET
011
022011
103CS1P
011-LG-0035-B
3/4"-JET-011022011-103CS1P-P
-
-
P
25
KERO
Liquid
624
1.20
214.00
-
-
18.30
SA-JER-DS011-TRJR-480052
2"
JET
011
022012
101CS1P
20"-JET-011022007-101CS1P-H
Insul Brk
-
-
H
50
KERO
Liquid
624
1.20
205.00
-
-
3.70
200.00
TEST CONDITIONS
Rev Date:
SA-JER-DS011-TRJR-480052
KERO
7.00
STRESS TEMP
SA-JER-DS011-TRJR-380001
SA-JER-DS011-TRJR-480052
SA-JER-DS011-TRJR-480052
3/4"
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
DOC. No.
-1.00
250.00
250.00
By Code
Q
SA-JER-DS011-TRJR-480052
2"
JET
011
022012
101CS1P
Insul Brk
2"-CLD-011022302-101CH2S-P
-
-
P
40
KERO
Liquid
624
1.20
205.00
-
-
3.70
250.00
-
H
5.81
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
3/4"
JET
011
022012
101CS1P
2"-JET-011022012-101CS1P-P
Plug
-
-
P
25
KERO
Liquid
624
1.20
205.00
-
-
3.70
250.00
-
H
5.81
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
4"
JET
011
022017
103CS1P
011-G-0009-B
Reducer
-
-
H
65
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
8"
JET
011
022017
103CS1P
Reducer
8"-JET-011022017-103CS1P-H
-
-
H
65
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
3/4"
JET
011
022017
103CS1P
8"-JET-011022017-103CS1P-H
011-PI-0048
-
-
H
40
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
3/4"
JET
011
022017
103CS1P
8"-JET-011022017-103CS1P-H
8"-JET-011022017-103CS1P-H
-
-
H
40
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
8"
JET
011
022017
103CS1P
8"-JET-011022017-103CS1P-H
8"-JET-011022006-103CS1P-H
-
-
H
65
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480053
2"
JET
011
022018
103CS1P
8"-JET-011022006-103CS1P-H
Insul Brk
-
-
H
50
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
2"
JET
011
022018
103CS1P
Insul Brk
2"-CLD-011022307-101CH2S-P
-
-
P
40
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
-
-
P
25
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
3/4"
JET
011
022018
103CS1P
2"-JET-011022018-103CS1P-P
3/4"-OLW-011022302-101CS1PN
SA-JER-DS011-TRJR-480053
2"
JET
011
022018
103CS1P
12"-JET-011022004-103CS1P-H
Insul Brk
-
-
H
50
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
2"
JET
011
022018
103CS1P
Insul Brk
2"-JET-011022018-103CS1P-P
-
-
P
40
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
3/4"
JET
011
022018
103CS1P
011-G-0009-A
Reducer
-
-
P
25
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
1"
JET
011
022018
103CS1P
Reducer
2"-JET-011022018-103CS1P-P
-
-
P
25
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
3/4"
JET
011
022018
103CS1P
011-G-0009-A
2"-JET-011022018-103CS1P-P
-
-
P
25
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
3/4"
JET
011
022018
103CS1P
Gate valve
3/4"-JET-011022018-103CS1P-P
-
-
P
25
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
2"
JET
011
022019
103CS1P
8"-JET-011022017-103CS1P-H
Insul Brk
-
-
H
50
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
2"
JET
011
022019
103CS1P
Insul Brk
2"-CLD-011022308-101CH2S-P
-
-
P
40
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
-
-
P
25
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
3/4"
JET
011
022019
103CS1P
2"-JET-011022019-103CS1P-P
3/4"-OLW-011022303-101CS1PN
SA-JER-DS011-TRJR-480053
2"
JET
011
022019
103CS1P
12"-JET-011022005-103CS1P-H
Insul Brk
-
-
H
50
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
2"
JET
011
022019
103CS1P
Insul Brk
2"-JET-011022019-103CS1P-P
-
-
P
40
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
3/4"
JET
011
022019
103CS1P
011-G-0009-B
Reducer
-
-
P
25
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
1"
JET
011
022019
103CS1P
Reducer
2"-JET-011022019-103CS1P-P
-
-
P
25
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
3/4"
JET
011
022019
103CS1P
011-G-0009-B
2"-JET-011022019-103CS1P-P
-
-
P
25
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480053
3/4"
JET
011
022019
103CS1P
Gate valve
3/4"-JET-011022019-103CS1P-P
-
-
P
25
KERO
Liquid
624
12.00
214.00
-
-
18.30
250.00
-
H
28.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
2"
JET
011
022020
101CS1P
011-C-0004
2"-OLW-011022304-101CS1P-N
-
-
H
50
KERO
Liquid
624
1.20
214.00
-
-
3.70
250.00
-
H
5.81
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-1.00
250.00
250.00
-
SA-JER-DS011-TRJR-480052
4"
JET
011
022021
101CS1P
011-C-0004
4"-OLW-011022305-101CS1P-N
-
-
H
65
KERO
Liquid
624
1.20
214.00
-
-
3.70
-
H
5.81
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
12"
JET
011
022022
101CS1P
011-C-0004
011-ZV-0011
-
-
H
100
KERO
Liquid
624
1.20
214.00
-
-
3.70
250.00
-
H
5.81
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
3/4"
JET
011
022023
103CS1P
011-LG-0035-A
3/4"-LFL-011022301-101CH2F-N
-
-
P
25
KERO
Gas
-
1.10
187.00
-
-
3.70
220.00
-
H
5.64
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
3/4"
JET
011
022023
103CS1P
3/4"-JET-011022023-103CS1P-P
Plug
-
-
P
25
KERO
Gas
-
1.10
187.00
-
-
3.70
220.00
-
H
5.64
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480052
3/4"
JET
011
022023
103CS1P
011-LG-0035-B
3/4"-JET-011022023-103CS1P-P
-
-
P
25
KERO
Gas
-
1.10
187.00
-
-
3.70
220.00
-
H
5.64
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITION : 0.5 bara (HALF VACUUM) @ 150ºC
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITION : 0.5 bara (HALF VACUUM) @ 150ºC
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150ºC
if insulated N or Q SA-JER-DS011-TRJR-480052
-
JET
011
022601
103CS1P
011-C-0004
TRIM
-
-
H
-
-
-
-
1.10
187.00
-
-
3.70
220.00
-
Visual Test
0.00
NFS
By Code
SA-JER-DS011-TRJR-480052
4"
JET
011
022601
103CS1P
011-C-0004
Blind flange
-
-
H
50
-
-
-
1.10
187.00
-
-
3.70
220.00
-
H
5.64
NFS
By Code
SA-JER-DS011-TRJR-480052
-
JET
011
022602
101CS1P
011-C-0004
TRIM
-
-
H
-
-
-
-
1.10
187.00
-
-
3.70
220.00
-
Visual Test
0.00
NFS
By Code
if NOT insulated B or Q if insulated N or Q if NOT insulated B or Q if insulated N or Q if NOT insulated B or Q
SA-JER-DS011-TRJR-480058
8"
JET
011
025001
103CS1P
8"-JET-011001001-103CS1P-H
Reducer
-
-
H
40
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
1/2"
JET
011
025001
103CS1P
011-FE-0118
011-FT-0118
-
-
H
25
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
6"
JET
011
025001
103CS1P
Reducer
6"-JET-011025001-103CS1P-H
-
-
H
40
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
8"
JET
011
025001
103CS1P
8"-JET-011025001-103CS1P-H
Reducer
-
-
H
40
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
1/2"
JET
011
025001
103CS1P
011-FE-0118
011-FT-0118
-
-
H
25
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
6"
JET
011
025001
103CS1P
Reducer
Reducer
-
-
H
40
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480135
8"
JET
011
025001
103CS1P
SA-JER-DS011-TRJR-480058
8"-JET-011025001-103CS1P-H
-
-
H
40
KERO
Liquid
523
7.00
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
8"-JET-011025001-103CS1P-H
IP-1301-L
-
-
H
40
KERO
Liquid
523
7.00
70.00
-
-
20.00
237.00
-
H
31.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
25
523
7.00
70.00
-
-
20.00
237.00
-
H
31.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480135
8"
JET
011
025001
103CS1P
SA-JER-DS011-TRJR-480135
3/4"
JET
011
025001
103CS1P
8"-JET-011025001-103CS1P-H
Plug
-
KERO
Liquid
SA-JER-DS011-TRJR-480135
3/4"
JET
011
025001
103CS1P
011-PI-0337
8"-JET-011025001-103CS1P-H
-
-
H
25
KERO
Liquid
523
7.00
70.00
-
-
20.00
237.00
-
H
31.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
8"
JET
011
025001
103CS1P
Reducer
8"-JET-011025001-103CS1P-H
-
-
H
40
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
8"
JET
011
025001
103CS1P
8"-JET-011025001-103CS1P-H
SA-JER-DS011-TRJR-480135
-
-
H
40
KERO
Liquid
747
7.00
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
8"
JET
011
025001
103CS1P
Reducer
8"-JET-011025001-103CS1P-H
-
-
H
40
KERO
Liquid
747
7.00
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
6"
JET
011
025001
103CS1P
6"-JET-011025001-103CS1P-H
Reducer
-
-
H
40
KERO
Liquid
747
7.00
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
8"
JET
011
025002
103CS1P
011-E-0023
Reducer
-
-
N
-
KERO
Liquid
765
10.00
43.00
-
-
18.30
80.00
-
H
27.45
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
4"
JET
011
025002
103CS1P
Reducer
Reducer
-
-
N
-
KERO
Liquid
765
10.00
43.00
-
-
18.30
80.00
-
H
27.45
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480133
8"
JET
011
025002
103CS1P
SA-JER-DS011-TRJR-480058
8"-JET-011025002-103CS1P-N
-
-
N
-
KERO
Liquid
765
6.90
43.00
-
-
18.30
80.00
-
H
27.45
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480133
8"
JET
011
025002
103CS1P
8"-JET-011025002-103CS1P-N
IP-1317-L
-
-
N
-
KERO
Liquid
765
6.90
43.00
-
-
23.30
80.00
-
H
34.95
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
8"
JET
011
025002
103CS1P
Reducer
8"-JET-011025002-103CS1P-N
-
-
N
-
KERO
Liquid
765
10.00
43.00
-
-
18.30
80.00
-
H
27.45
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
8"
JET
011
025002
103CS1P
8"-JET-011025002-103CS1P-N
SA-JER-DS011-TRJR-480133
-
-
N
-
KERO
Liquid
765
6.90
43.00
-
-
18.30
80.00
-
H
27.45
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
2"
JET
011
025002
103CS1P
8"-JET-011025002-103CS1P-N
2"-JET-011025007-103CS1P-N
-
-
N
-
KERO
Liquid
765
10.00
43.00
-
-
18.30
80.00
-
H
27.45
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
3/4"
JET
011
025003
103CS1P
8"-JET-011025001-103CS1P-H
Insul Brk
-
-
H
25
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
3/4"
JET
011
025003
103CS1P
Insul Brk
Reducer
-
-
P
25
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
3/4"
JET
011
025003
103CS1P
3/4"-JET-011025003-103CS1P-P
Plug
-
-
P
25
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
2"
JET
011
025003
103CS1P
Reducer
2"-CLD-011025302-101CH2S-P
-
-
P
25
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
3/4"
JET
011
025003
103CS1P
8"-JET-011025001-103CS1P-H
Insul Brk
-
-
H
25
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
3/4"
JET
011
025003
103CS1P
Insul Brk
3/4"-JET-011025003-103CS1P-P
-
-
P
25
KERO
Liquid
747
10.50
70.00
-
-
18.30
175.00
-
H
27.45
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
2"
JET
011
025007
103CS1P
2"-JET-011025002-103CS1P-N
2"-CLD-011025313-101CH2S-P
-
-
N
-
KERO
Liquid
765
10.00
43.00
-
-
18.30
80.00
-
H
27.45
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
3/4"
JET
011
025008
103CS1P
8"-JET-011025002-103CS1P-N
Reducer
-
-
N
-
KERO
Liquid
765
10.00
43.00
-
-
18.30
80.00
-
H
27.45
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
2"
JET
011
025008
103CS1P
Reducer
2"-CLD-011025301-101CH2S-N
-
-
N
-
KERO
Liquid
765
10.00
43.00
-
-
18.30
80.00
-
H
27.45
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
3/4"
JET
011
025008
103CS1P
8"-JET-011025002-103CS1P-N
3/4"-JET-011025008-103CS1P-N
-
-
N
-
KERO
Liquid
765
10.00
43.00
-
-
18.30
80.00
-
H
27.45
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
3/4"
JET
011
025009
103CS1P
8"-JET-011025002-103CS1P-N
011-SC-0019
-
-
N
-
KERO
Liquid
765
10.00
43.00
-
-
18.30
80.00
-
H
27.45
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480058
3/4"
JET
011
025010
103CS1P
011-SC-0019
8"-JET-011025002-103CS1P-N
-
-
N
-
KERO
Liquid
765
6.90
43.00
-
-
18.30
80.00
-
H
27.45
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
12"
JET
011
026001
101CS1P
011-G-0008-A
Reducer
-
-
H
65
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
16"
JET
011
026001
101CS1P
Reducer
16"-JET-011026001-101CS1P-H
-
-
H
65
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
3/4"
JET
011
026001
101CS1P
16"-JET-011026001-101CS1P-H
16"-JET-011026001-101CS1P-H
-
-
H
40
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
3/4"
JET
011
026001
101CS1P
16"-JET-011026001-101CS1P-H
011-PI-0057
-
-
H
40
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
16"
JET
011
026001
101CS1P
SA-JER-DS011-TRJR-480063
Reducer
-
-
H
65
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
16"
JET
011
026001
101CS1P
16"-JET-011026001-101CS1P-H
Reducer
-
-
H
65
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 102 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9) JET
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
011
INSULATION (NOTE 2)
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480008
10"
026001
101CS1P
Reducer
10"-JET-011026001-101CS1P-H
-
-
H
65
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
3/4"
JET
011
026001
101CS1P
16"-JET-011026001-101CS1P-H
011-PDT-0449
-
-
H
40
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
10"
JET
011
026001
101CS1P
Reducer
Reducer
-
-
H
65
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
16"
JET
011
026001
101CS1P
Reducer
16"-JET-011026001-101CS1P-H
-
-
H
65
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
10"
JET
011
026001
101CS1P
10"-JET-011026001-101CS1P-H
Reducer
-
-
H
65
KERO
Liquid
656
7.46
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
16"
JET
011
026001
101CS1P
16"-JET-011026001-101CS1P-H
Reducer
-
-
H
65
KERO
Liquid
656
7.46
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
16"
JET
011
026001
101CS1P
16"-JET-011026001-101CS1P-H
Reducer
-
-
H
65
KERO
Liquid
656
7.46
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
16"-JET-011026001-101CS1P-H
011-TT-0244
-
-
H
40
KERO
Liquid
656
7.46
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
H
65
656
7.46
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
2"
JET
011
026001
101CS1P
SA-JER-DS011-TRJR-480008
16"
JET
011
026001
101CS1P
Reducer
16"-JET-011026001-101CS1P-H
-
KERO
Liquid
SA-JER-DS011-TRJR-480008
12"
JET
011
026001
101CS1P
Reducer
011-E-0007 A/C
-
-
H
65
KERO
Liquid
656
7.46
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480008
12"
JET
011
026001
101CS1P
Reducer
011-E-0007-C
-
-
H
65
KERO
Liquid
656
7.46
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
16"
JET
011
026001
101CS1P
16"-JET-011026001-101CS1P-H
SA-JER-DS011-TRJR-480008
-
-
H
65
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
8"
JET
011
026002
101CS1P
16"-JET-011026001-101CS1P-H
SA-JER-DS011-TRJR-480043
-
-
H
65
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
8"
JET
011
026002
101CS1P
SA-JER-DS011-TRJR-480063
Reducer
-
-
H
65
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
1/2"
JET
011
026002
101CS1P
011-FE-0018
011-FT-0018
-
-
H
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
4"
JET
011
026002
101CS1P
Reducer
4"-JET-011026002-101CS1P-H
-
-
H
50
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
1/2"
JET
011
026002
101CS1P
011-FE-0018
011-FT-0018
-
-
H
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
6"
JET
011
026002
101CS1P
8"-JET-011026002-101CS1P-H
Reducer
-
-
H
50
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
6"
JET
011
026002
101CS1P
Reducer
Reducer
-
-
H
50
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
8"
JET
011
026002
101CS1P
Reducer
8"-JET-011026002-101CS1P-H
-
-
H
65
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
8"
JET
011
026002
101CS1P
8"-JET-011026002-101CS1P-H
011-C-0002
-
-
H
65
KERO
Liquid
656
5.20
170.00
-
-
6.50
280.00
-
H
10.64
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
4"
JET
011
026002
101CS1P
4"-JET-011026002-101CS1P-H
Reducer
-
-
H
50
KERO
Liquid
656
5.20
170.00
-
-
6.50
280.00
-
H
10.64
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
6"
JET
011
026002
101CS1P
Reducer
8"-JET-011026002-101CS1P-H
-
-
H
50
KERO
Liquid
656
5.20
170.00
-
-
6.50
280.00
-
H
10.64
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
18"
JET
011
026003
101CS1P
18"-JET-011018001-101CS1P-H
Reducer
-
-
H
65
KERO
Liquid
657
4.60
171.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
2"
JET
011
026003
101CS1P
18"-JET-011026003-101CS1P-H
UC
-
-
H
40
KERO
Liquid
657
4.60
171.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
3/4"
JET
011
026003
101CS1P
18"-JET-011026003-101CS1P-H
011-PI-0199
-
-
H
40
KERO
Liquid
657
4.60
171.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
14"
JET
011
026003
101CS1P
Reducer
011-G-0008-A
-
-
H
65
KERO
Liquid
657
4.60
171.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
18"
JET
011
026004
101CS1P
18"-JET-011018001-101CS1P-H
Reducer
-
-
H
65
KERO
Liquid
657
4.60
171.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
3/4"
JET
011
026004
101CS1P
18"-JET-011026004-101CS1P-H
011-PI-0202
-
-
H
40
KERO
Liquid
657
4.60
171.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
2"
JET
011
026004
101CS1P
18"-JET-011026004-101CS1P-H
UC
-
-
H
40
KERO
Liquid
657
4.60
171.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
14"
JET
011
026004
101CS1P
Reducer
011-G-0008-B
-
-
H
65
KERO
Liquid
657
4.60
171.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
12"
JET
011
026005
101CS1P
011-G-0008-B
Reducer
-
-
H
65
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
16"
JET
011
026005
101CS1P
Reducer
16"-JET-011026005-101CS1P-H
-
-
H
65
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
3/4"
JET
011
026005
101CS1P
16"-JET-011026005-101CS1P-H
16"-JET-011026005-101CS1P-H
-
-
H
40
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
3/4"
JET
011
026005
101CS1P
16"-JET-011026005-101CS1P-H
011-PI-0058
-
-
H
40
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
16"
JET
011
026005
101CS1P
16"-JET-011026005-101CS1P-H
16"-JET-011026001-101CS1P-H
-
-
H
65
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
2"
JET
011
026006
101CS1P
16"-JET-011026001-101CS1P-H
Insul Brk
-
-
H
40
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
2"
JET
011
026006
101CS1P
Insul Brk
2"-CLD-011026301-101CH2S-P
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
3/4"
JET
011
026006
101CS1P
2"-JET-011026006-101CS1P-P
3/4"-OLW-011026301-101CS1PN
SA-JER-DS011-TRJR-480063
3/4"
JET
011
026006
101CS1P
18"-JET-011026003-101CS1P-H
Insul Brk
-
-
H
40
KERO
Liquid
661
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
3/4"
JET
011
026006
101CS1P
Insul Brk
2"-JET-011026006-101CS1P-P
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
2"
JET
011
026006
101CS1P
14"-JET-011026003-101CS1P-H
2"-JET-011026006-101CS1P-P
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
2"
JET
011
026006
101CS1P
2"-JET-011026006-101CS1P-P
2"-JET-011026006-101CS1P-P
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
3/4"
JET
011
026006
101CS1P
011-G-0008-A
Reducer
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
2"
JET
011
026006
101CS1P
Reducer
2"-JET-011026006-101CS1P-P
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
3/4"
JET
011
026006
101CS1P
011-G-0008-A
2"-JET-011026006-101CS1P-P
-
-
P
25
NAPHTHA
Gas
-
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
3/4"
JET
011
026006
101CS1P
011-G-0008-A
2"-JET-011026006-101CS1P-P
-
-
P
25
NAPHTHA
Gas
-
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
3/4"
JET
011
026006
101CS1P
011-G-0008-A
2"-JET-011026006-101CS1P-P
-
-
P
25
NAPHTHA
Gas
-
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
2"
JET
011
026007
101CS1P
16"-JET-011026005-101CS1P-H
Insul Brk
-
-
H
40
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
3/4"
JET
011
026007
101CS1P
011-G-0008-B
2"-JET-011026007-101CS1P-P
-
-
P
25
NAPHTHA
Gas
-
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
2"
JET
011
026007
101CS1P
Insul Brk
2"-CLD-011026302-101CH2S-P
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
3/4"
JET
011
026007
101CS1P
2"-JET-011026007-101CS1P-P
3/4"-OLW-011026302-101CS1PN
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
3/4"
JET
011
026007
101CS1P
18"-JET-011026004-101CS1P-H
Insul Brk
-
-
H
40
KERO
Liquid
661
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
3/4"
JET
011
026007
101CS1P
Insul Brk
2"-JET-011026007-101CS1P-P
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
2"
JET
011
026007
101CS1P
14"-JET-011026004-101CS1P-H
2"-JET-011026007-101CS1P-P
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
2"
JET
011
026007
101CS1P
2"-JET-011026007-101CS1P-P
2"-JET-011026007-101CS1P-P
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
3/4"
JET
011
026007
101CS1P
011-G-0008-B
Reducer
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
2"
JET
011
026007
101CS1P
Reducer
2"-JET-011026007-101CS1P-P
-
-
P
25
KERO
Liquid
656
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
3/4"
JET
011
026007
101CS1P
011-G-0008-B
2"-JET-011026007-101CS1P-P
-
-
P
25
NAPHTHA
Gas
-
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480063
3/4"
JET
011
026007
101CS1P
011-G-0008-B
2"-JET-011026007-101CS1P-P
-
-
P
25
NAPHTHA
Gas
-
8.40
170.00
-
-
12.50
200.00
-
H
18.75
NFS
By Code
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480133
8"
JET
011
098001
103CS1P
8"-JET-011025002-103CS1P-N
SA-JER-DS011-TRJR-480136
-
-
N
-
KERO
Liquid
765
6.90
43.00
-
-
18.30
80.00
-
H
27.45
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
8"
JET
011
098001
103CS1P
SA-JER-DS011-TRJR-480133
8"-SLP-011099001-103CS1P-S
-
-
N
-
KERO
Liquid
862.5
6.90
43.00
-
-
18.30
80.00
-
H
27.45
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480135
3/4"
JET
011
098002
103CS1P
8"-JET-011025001-103CS1P-H
Insul Brk
-
-
H
25
KERO
Liquid
523
7.00
70.00
-
-
20.00
237.00
-
H
31.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480135
3/4"
JET
011
098002
103CS1P
Insul Brk
Reducer
-
-
P
25
KERO
Liquid
523
7.00
70.00
-
-
20.00
237.00
-
H
31.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480135
3/4"
JET
011
098002
103CS1P
3/4"-JET-011098002-103CS1P-P
UC
-
-
P
25
KERO
Liquid
523
7.00
70.00
-
-
20.00
237.00
-
H
31.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480135
2"
JET
011
098002
103CS1P
Reducer
2"-CLD-011098310-101CH2S-P
-
-
P
25
KERO
Liquid
523
7.00
70.00
-
-
20.00
237.00
-
H
31.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480135
3/4"
JET
011
098002
103CS1P
8"-JET-011025001-103CS1P-H
Insul Brk
-
-
H
25
KERO
Liquid
523
7.00
70.00
-
-
20.00
237.00
-
H
31.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480135
3/4"
JET
011
098002
103CS1P
Insul Brk
3/4"-JET-011098002-103CS1P-P
-
-
P
25
KERO
Liquid
523
7.00
70.00
-
-
20.00
237.00
-
H
31.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480133
3/4"
JET
011
098003
103CS1P
8"-JET-011025002-103CS1P-N
Reducer
-
-
N
-
KERO
Liquid
765
6.90
43.00
-
-
23.30
80.00
-
H
34.95
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480133
2"
JET
011
098003
103CS1P
Reducer
2"-CLD-011098311-101CH2S-P
-
-
N
-
KERO
Liquid
765
6.90
43.00
-
-
23.30
80.00
-
H
34.95
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480133
3/4"
JET
011
098003
103CS1P
8"-JET-011025002-103CS1P-N
3/4"-JET-011098003-103CS1P-N
-
-
N
-
KERO
Liquid
765
6.90
43.00
-
-
23.30
80.00
-
H
34.95
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
8"
JET
011
098004
103CS1P
8"-JET-011098001-103CS1P-N
Insul Brk
-
-
N
-
KERO
Liquid
837
6.90
43.00
-
-
18.30
80.00
-
H
27.45
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
8"
JET
011
098004
103CS1P
Insul Brk
8"-JET-011098004-103CS1P-S
S
41
H
40
KERO
Liquid
837
6.90
43.00
-
-
18.30
155.00
-
H
27.45
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
8"
JET
011
098004
103CS1P
8"-JET-011098004-103CS1P-S
8"-HFO-011098012-103CS1P-S
S
41
H
40
KERO
Liquid
846
6.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
JET
011
200001
103CS1P
3/4"-JET-011025010-103CS1P-N
Reducer
-
-
N
-
KERO
Liquid
765
6.90
43.00
-
-
18.30
80.00
-
H
27.45
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
2"
JET
011
200001
103CS1P
Reducer
2"-CLD-011200306-101CH2S-N
-
-
N
-
KERO
Liquid
765
6.90
43.00
-
-
18.30
80.00
-
H
27.45
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480001
4"
LFL
011
001301
101CH2F
011-PZV-0078-A
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR BLOCKED OUTLET: 43º C. NOTE 10
SA-JER-DS011-TRJR-480001
8"
LFL
011
001301
101CH2F
Reducer
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR BLOCKED OUTLET: 43º C. NOTE 10
SA-JER-DS011-TRJR-480218
8"
LFL
011
001301
101CH2F
SA-JER-DS011-TRJR-480001
44"-LFL-011076301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 43°C NOTE 10
SA-JER-DS011-TRJR-480001
4"
LFL
011
001301
101CH2F
011-PZV-0078-B
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR BLOCKED OUTLET: 43°C. NOTE 10
SA-JER-DS011-TRJR-480001
8"
LFL
011
001301
101CH2F
Reducer
8"-LFL-011001301-101CH2F-N
SA-JER-DS011-TRJR-480001
3/4"
LFL
011
001301
101CH2F
3/4"-SLP-011001002-103CS1P-N
8"-LFL-011001301-101CH2F-N
SA-JER-DS011-TRJR-480001
3/4"
LFL
011
001301
101CH2F
SA-JER-DS011-TRJR-480004
2"
LFL
011
002301
101CH2F
2"-NAP-011002004-101CH2S-P
SA-JER-DS011-TRJR-480004
2"
LFL
011
002301
101CH2F
SA-JER-DS011-TRJR-480220
2"
LFL
011
002301
SA-JER-DS011-TRJR-480005
2"
LFL
011
SA-JER-DS011-TRJR-480020
2"
LFL
SA-JER-DS011-TRJR-480010
6"
LFL
SA-JER-DS011-TRJR-380001
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR BLOCKED OUTLET: 43º C. NOTE 10
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR BLOCKED OUTLET: 43º C.
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR BLOCKED OUTLET: 43º C.
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
2"-NAP-011002009-101CH2S-P
2"-LFL-011002301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
101CH2F
SA-JER-DS011-TRJR-480004
42"-LFL-011018301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
003001
101CH2F
2"-NAP-011003005-101CH2S-P
SA-JER-DS011-TRJR-480020
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
011
003001
101CH2F
SA-JER-DS011-TRJR-480005
24"-LFL-011011301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200°C NOTE 10
011
005301
101CH2F
011-TZV-0013
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE IN OTHER CASE: 294 ºC. NOTE 10
3/4"-SLP-011001002-103CS1P-N 3/4"-LFL-011001301-101CH2F-N
-
Page 103 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480010
8"
LFL
011
005301
101CH2F
Reducer
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480218
8"
LFL
011
005301
101CH2F
SA-JER-DS011-TRJR-480010
44"-LFL-011076301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
10"
LFL
011
006301
101CH2F
011-PZV-0001
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
24"
LFL
011
006301
101CH2F
Reducer
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480218
24"
LFL
011
006301
101CH2F
SA-JER-DS011-TRJR-480011
44"-LFL-011076301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
3/4"
LFL
011
006301
101CH2F 3/4"-CRU-011006003-103CS1P-H 24"-LFL-011006301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
3/4"
LFL
011
006301
101CH2F 3/4"-CRU-011006003-103CS1P-H 3/4"-LFL-011006301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
10"
LFL
011
006302
101CH2F
011-PZV-0002
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
24"
LFL
011
006302
101CH2F
Reducer
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480218
24"
LFL
011
006302
101CH2F
SA-JER-DS011-TRJR-480011
44"-LFL-011076301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
4"
LFL
011
006302
101CH2F
4"-CRU-011006003-103CS1P-H
24"-LFL-011006302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
3/4"
LFL
011
006303
101CH2F 3/4"-CRU-011006014-103CS1P-P
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480011
1"
LFL
011
006303
101CH2F
Reducer
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480011
1"
LFL
011
006303
101CH2F
011-TZV-0080
1"-LFL-011006303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
1"
LFL
011
006303
101CH2F
SA-JER-DS011-TRJR-480011
2"-LFL-011007303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480011
1"
LFL
011
006303
101CH2F
011-TZV-0081
1"-LFL-011006303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480011
1"
LFL
011
006303
101CH2F
1"-LFL-011006303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
10"
LFL
011
007301
101CH2F
SA-JER-DS011-TRJR-480012
24"
LFL
011
007301
101CH2F
SA-JER-DS011-TRJR-480218
24"
LFL
011
007301
101CH2F
SA-JER-DS011-TRJR-480012
3/4"
LFL
011
SA-JER-DS011-TRJR-480012
3/4"
LFL
SA-JER-DS011-TRJR-480012
10"
SA-JER-DS011-TRJR-480012
24"
SA-JER-DS011-TRJR-480218 SA-JER-DS011-TRJR-480012
011-TZV-0082
MAX. TEMPERATURE IN OTHER CASE: 294 ºC. NOTE 10 MAX. TEMPERATURE FOR OTHER CASES: 294°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 200°C MAX.TEMPERATURE FOR OTHER CASEAS 148°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 200°C MAX.TEMPERATURE FOR OTHER CASEAS 148°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC. MAX. TEMPERATURE FOR OTHER CASES: 148°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 200°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 200°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 200°C MAX.TEMPERATURE FOR OTHER CASEAS 148°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 200°C MAX.TEMPERATURE FOR OTHER CASEAS 148°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC. MAX. TEMPERATURE FOR OTHER CASES: 148°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 200°C NOTE 10
MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC. NOTE 10. MAX. TEMPERATURE FOR OTHER CASES: 145 ºC. MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC. NOTE 10. MAX. TEMPERATURE FOR OTHER CASES: 145 ºC. -
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
Reducer
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
44"-LFL-011076301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
NFS
YES
A or Q
Y
N
N
N
N
N
-
007301
101CH2F 3/4"-CRU-011007012-103CS1P-H 24"-LFL-011007301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
011
007301
101CH2F 3/4"-CRU-011007012-103CS1P-H 3/4"-LFL-011007301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
LFL
011
007302
101CH2F
011-PZV-0004
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
LFL
011
007302
101CH2F
Reducer
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
NFS
YES
A or Q
Y
N
N
N
N
N
-
24"
LFL
011
007302
101CH2F
SA-JER-DS011-TRJR-480012
44"-LFL-011076301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
NFS
YES
A or Q
Y
N
N
N
N
N
-
4"
LFL
011
007302
101CH2F
4"-CRU-011007012-103CS1P-H
24"-LFL-011007302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480012
3/4"
LFL
011
007303
101CH2F 3/4"-CRU-011007020-103CS1P-P
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC. NOTE 10MAX. TEMPERATURE FOR OTHER CASES: 145 ºC. MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC. NOTE 10MAX. TEMPERATURE FOR OTHER CASES: 145 ºC. MAX. TEMPERATURE FOR OTHER CASES: 145 ºC.NOTE 10. MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC MAX. TEMPERATURE FOR OTHER CASES: 145 ºC. NOTE 10. MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC. MAX. TEMPERATURE FOR OTHER CASES: 145°C NOTE 10 MAX. TEMPERATURE FOR OTHER CASES: 145 ºC. NOTE 10. MAX. TEMPERATURE DURING FIRE SCENARIO: 200º C -
SA-JER-DS011-TRJR-480012
1"
LFL
011
007303
101CH2F
Reducer
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
1"
LFL
011
007303
101CH2F
SA-JER-DS011-TRJR-480012
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
2"
LFL
011
007303
101CH2F
Reducer
44"-LFL-011076301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480012
1"
LFL
011
007303
101CH2F
011-TZV-0083
1"-LFL-011007303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480012
1"
LFL
011
007303
101CH2F
011-TZV-0084
1"-LFL-011007303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480012
1"
LFL
011
007303
101CH2F
011-TZV-0085
1"-LFL-011007303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480019
4"
LFL
011
010301
101CH2F
011-TZV-0017
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480019
6"
LFL
011
010301
101CH2F
Reducer
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480218
6"
LFL
011
010301
101CH2F
SA-JER-DS011-TRJR-480019
24"-LFL-011076301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
NOTE 10; MAX TEMPERATURE FOR THERMAL EXPANSION 283ºC NOTE 10, MAX TEMPERATURE FOR THERMAL EXPANSION 283ºC -
SA-JER-DS011-TRJR-480020
24"
LFL
011
011301
101CH2F
HEADER
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 10
SA-JER-DS011-TRJR-480020
3/4"
LFL
011
011301
101CH2F
3/4"-NAP-011011001-101CH2S-P 3/4"-LFL-011011301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480020
3/4"
LFL
011
011301
101CH2F
3/4"-NAP-011011001-101CH2S-P 3/4"-LFL-011011301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200°C. NOTE 10
SA-JER-DS011-TRJR-480020
10"
LFL
011
011301
101CH2F
011-PZV-0005-B
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 10
SA-JER-DS011-TRJR-480218
24"
LFL
011
011301
101CH2F
SA-JER-DS011-TRJR-480020
24"-LFL-011076301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200°C NOTE 10
SA-JER-DS011-TRJR-480020
14"
LFL
011
011301
101CH2F
Reducer
24"-LFL-011011301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 10
SA-JER-DS011-TRJR-480020
10"
LFL
011
011301
101CH2F
011-PZV-0005-A
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 10
SA-JER-DS011-TRJR-480020
14"
LFL
011
011301
101CH2F
Reducer
24"-LFL-011011301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 10
SA-JER-DS011-TRJR-480020
10"
LFL
011
011301
101CH2F
011-PZV-0006
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 10
SA-JER-DS011-TRJR-480020
14"
LFL
011
011301
101CH2F
Reducer
24"-LFL-011011301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 10
SA-JER-DS011-TRJR-480020
2"
LFL
011
011301
101CH2F
2"-NAP-011011001-101CH2S-P
24"-LFL-011011301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 10
SA-JER-DS011-TRJR-480020
3/4"
LFL
011
011301
101CH2F
SA-JER-DS011-TRJR-480020
3/4"
LFL
011
011302
101CH2F 3/4"-CRU-011011302-101CS1P-P
SA-JER-DS011-TRJR-480218
3/4"
LFL
011
011302
101CH2F
SA-JER-DS011-TRJR-480020
3/4"
LFL
011
011303
101CH2F 3/4"-CRU-011011301-101CS1P-P
SA-JER-DS011-TRJR-480218
3/4"
LFL
011
011303
101CH2F
SA-JER-DS011-TRJR-480023
8"
LFL
011
012301
101CH2F
SA-JER-DS011-TRJR-480023
14"
LFL
011
012301
101CH2F
SA-JER-DS011-TRJR-480218
14"
LFL
011
012301
101CH2F
011-PZV-0003
-
MAX. TEMPERATURE FOR OTHER CASES: 200°C. NOTE 10
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 10
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
3/4"-LFL-011011303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480020
24"-LFL-011011301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
011-PZV-0008
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
Reducer
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480023
24"-LFL-011076301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
3/4"-NAP-011011001-101CH2S-P 24"-LFL-011011301-101CH2F-N
SA-JER-DS011-TRJR-480020
-
SA-JER-DS011-TRJR-480023
2"
LFL
011
012301
101CH2F
2"-NAP-011012003-101CH2S-P
14"-LFL-011012301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480023
3/4"
LFL
011
012302
101CH2F
3/4"-NAP-011012016-101CH2S-P
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX TEMPERATURE FOR OTHER CASES: 110ºC. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX TEMPERATURE FOR OTHER CASES: 110ºC. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145ºC. MAX. TEMPERATURE FOR OTHER CASES: 110°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX TEMPERATURE FOR OTHER CASES: 110ºC. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX TEMPERATURE FOR OTHER CASES: 110ºC. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX TEMPERATURE FOR OTHER CASES: 110ºC. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX TEMPERATURE FOR OTHER CASES: 110ºC. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX TEMPERATURE FOR OTHER CASES: 110ºC. NOTE 10 -
SA-JER-DS011-TRJR-480218
3/4"
LFL
011
012302
101CH2F
SA-JER-DS011-TRJR-480023
14"-LFL-011012301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480023
3/4"
LFL
011
012303
101CH2F
3/4"-NAP-011012017-101CH2S-P
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
3/4"
LFL
011
012303
101CH2F
SA-JER-DS011-TRJR-480023
3/4"-LFL-011012302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 145ºC. MAX. TEMPERATURE FOR OTHER CASES: 110°C NOTE 10
SA-JER-DS011-TRJR-480141
2"
LFL
011
013301
101CH2F
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 425ºC.
SA-JER-DS011-TRJR-480141
3"
LFL
011
013301
101CH2F
Reducer
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 425ºC.
SA-JER-DS011-TRJR-480221
3"
LFL
011
013301
101CH2F
SA-JER-DS011-TRJR-480141
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480141
2"
LFL
011
013301
101CH2F
2"-HFO-011013015-103SD0P-S
3"-LFL-011013301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 425ºC.
SA-JER-DS011-TRJR-480043
42"
LFL
011
018301
101CH2F
HEADER
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480043
10"
LFL
011
018301
101CH2F
011-PZV-0046-D
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480043
14"
LFL
011
018301
101CH2F
Reducer
42"-LFL-011018301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480043
10"
LFL
011
018301
101CH2F
011-PZV-0046-E
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480023
8"
LFL
011
012301
101CH2F
011-PZV-0007
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480023
14"
LFL
011
012301
101CH2F
Reducer
14"-LFL-011012301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480023
3/4"
LFL
011
012301
101CH2F
3/4"-NAP-011012003-101CH2S-P
2"-LFL-011012301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480023
3/4"
LFL
011
012301
101CH2F
3/4"-NAP-011012003-101CH2S-P 14"-LFL-011012301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
011-PZV-0075
MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10
Page 104 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
42"-LFL-011018301-101CH2F-N
-
-
N
-
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
(NOTE 7)
3/4"-NAP-011018002-101CH2S-P 42"-LFL-011018301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
3/4"-NAP-011018002-101CH2S-P 3/4"-LFL-011018301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
3/4"-NAP-011018002-101CH2S-P 3/4"-LFL-011018301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
101CH2F
3/4"-NAP-011018002-101CH2S-P 3/4"-LFL-011018301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
018301
101CH2F
3/4"-NAP-011018002-101CH2S-P 3/4"-LFL-011018301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
018301
101CH2F
3/4"-NAP-011018002-101CH2S-P 3/4"-LFL-011018301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
011
018301
101CH2F
3/4"-NAP-011018002-101CH2S-P 3/4"-LFL-011018301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
011
018301
101CH2F
3/4"-NAP-011018002-101CH2S-P 3/4"-LFL-011018301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
LFL
011
018301
101CH2F
Reducer
42"-LFL-011018301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
LFL
011
018301
101CH2F
SA-JER-DS011-TRJR-480043
42"-LFL-011076303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
NFS
YES
A or Q
Y
N
N
N
N
N
-
10"
LFL
011
018301
101CH2F
011-PZV-0046-A
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480043
14"
LFL
011
018301
101CH2F
Reducer
42"-LFL-011018301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480043
10"
LFL
011
018301
101CH2F
011-PZV-0046-B
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480043
14"
LFL
011
018301
101CH2F
Reducer
42"-LFL-011018301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480043
10"
LFL
011
018301
101CH2F
011-PZV-0046-C
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480043
14"
LFL
011
018301
101CH2F
Reducer
42"-LFL-011018301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480043
3/4"
LFL
011
018302
101CH2F
3/4"-JET-011018301-101CS1P-P
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX.TEMPERATURE DURING FIRE SCENARIO: 285ºC. MAX.TEMPERATURE FOR OTHER CASES:360ºC. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 -
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
018302
101CH2F
SA-JER-DS011-TRJR-480043
1"-LFL-011018310-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480044
3/4"
LFL
011
018303
101CH2F
3/4"-DIE-011018009-101CS2P-P
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
018303
101CH2F
SA-JER-DS011-TRJR-480044
1"-LFL-011018310-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480044
3/4"
LFL
011
018304
101CH2F
3/4"-HFO-011018006-101CL2P-P
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
018304
101CH2F
SA-JER-DS011-TRJR-480044
1"-LFL-011018310-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480044
1"
LFL
011
018310
101CH2F
1"-CRU-011018003-101CL4P-S
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
1"
LFL
011
018310
101CH2F
SA-JER-DS011-TRJR-480044
42"-LFL-011018301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480046
6"
LFL
011
019301
101CH2F
6"-NAP-011019005-101CH2S-P
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
6"
LFL
011
019301
101CH2F
SA-JER-DS011-TRJR-480046
42"-LFL-011018301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
6"
LFL
011
019301
101CH2F
Reducer
6"-LFL-011019301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480046
10"
LFL
011
019302
101CH2F
011-PZV-0011-A
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480046
3/4"
LFL
011
019302
101CH2F
3/4"-NAP-011019006-101CH2S-P 3/4"-LFL-011019302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480046
3/4"
LFL
011
019302
101CH2F
3/4"-NAP-011019006-101CH2S-P 3/4"-LFL-011019302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480046
3/4"
LFL
011
019302
101CH2F
3/4"-NAP-011019006-101CH2S-P 20"-LFL-011019302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480046
18"
LFL
011
019302
101CH2F
Reducer
20"-LFL-011019302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480220
20"
LFL
011
019302
101CH2F
SA-JER-DS011-TRJR-480046
42"-LFL-011018301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480046
20"
LFL
011
019302
101CH2F
Cap
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480046
10"
LFL
011
019302
101CH2F
011-PZV-0011-B
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480046
18"
LFL
011
019302
101CH2F
Reducer
20"-LFL-011019302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480046
10"
LFL
011
019302
101CH2F
011-PZV-0012
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480046
18"
LFL
011
019302
101CH2F
Reducer
20"-LFL-011019302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480045
2"
LFL
011
019303
101CH2F
2"-NAP-011019022-101CH2S-P
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
SA-JER-DS011-TRJR-480043
14"
LFL
011
018301
101CH2F
Reducer
SA-JER-DS011-TRJR-480043
10"
LFL
011
018301
101CH2F
011-PZV-0046-F
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480043
14"
LFL
011
018301
101CH2F
Reducer
42"-LFL-011018301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480043
10"
LFL
011
018301
101CH2F
011-PZV-0046-G
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480043
14"
LFL
011
018301
101CH2F
42"-LFL-011018301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480043
3/4"
LFL
011
018301
101CH2F
SA-JER-DS011-TRJR-480043
3/4"
LFL
011
018301
101CH2F
SA-JER-DS011-TRJR-480043
10"
LFL
011
018301
101CH2F
SA-JER-DS011-TRJR-480043
3/4"
LFL
011
018301
101CH2F
SA-JER-DS011-TRJR-480043
3/4"
LFL
011
018301
SA-JER-DS011-TRJR-480043
3/4"
LFL
011
SA-JER-DS011-TRJR-480043
3/4"
LFL
011
SA-JER-DS011-TRJR-480043
3/4"
LFL
SA-JER-DS011-TRJR-480043
3/4"
LFL
SA-JER-DS011-TRJR-480043
14"
SA-JER-DS011-TRJR-480220
42"
SA-JER-DS011-TRJR-480043
Reducer
011-PZV-0047
Reducer
-
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX. TEMPERATURE FOR OTHER CASES: 126°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX. TEMPERATURE FOR OTHER CASES: 126°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX. TEMPERATURE FOR OTHER CASES: 126°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX. TEMPERATURE FOR OTHER CASES: 126°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX. TEMPERATURE FOR OTHER CASES: 126°C NOTE 10 MAX.TEMPERATURE DURING FIRE SCENARIO:145ºC. MAX. TEMPERATURE FOR OTHER CASES: 126ºC. NOTE 10. MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX. TEMPERATURE FOR OTHER CASES: 126°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX. TEMPERATURE FOR OTHER CASES: 126°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX. TEMPERATURE FOR OTHER CASES: 126°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX. TEMPERATURE FOR OTHER CASES: 126°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX. TEMPERATURE FOR OTHER CASES: 126°C NOTE 10 -
SA-JER-DS011-TRJR-480220
2"
LFL
011
019303
101CH2F
SA-JER-DS011-TRJR-480045
42"-LFL-011018301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480046
3/4"
LFL
011
019304
101CH2F
3/4"-NAP-011019024-101CH2S-P
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
019304
101CH2F
SA-JER-DS011-TRJR-480046
3/4"-LFL-011019305-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480046
3/4"
LFL
011
019305
101CH2F
011-LDG-0025
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
019305
101CH2F
SA-JER-DS011-TRJR-480046
20"-LFL-011019302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480046
3/4"
LFL
011
019306
101CH2F
3/4"-NAP-011019029-101CH2S-P
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
019306
101CH2F
SA-JER-DS011-TRJR-480046
20"-LFL-011019302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480046
3/4"
LFL
011
019307
101CH2F
3/4"-NAP-011019030-101CH2S-P
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
019307
101CH2F
SA-JER-DS011-TRJR-480046
3/4"-LFL-011019306-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480048
2"
LFL
011
020301
101CH2F
2"-NAP-011020005-101CH2S-P
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
2"
LFL
011
020301
101CH2F
SA-JER-DS011-TRJR-480048
42"-LFL-011076303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480050
8"
LFL
011
021301
101CH2F
011-PZV-0014
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE FOR OTHER CASE:100ºC. MAX.TEMPERATURE DURING FIRE SCENARIO: 95ºC. NOTE 10
SA-JER-DS011-TRJR-480050
10"
LFL
011
021301
101CH2F
Reducer
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE FOR OTHER CASE:100ºC. MAX.TEMPERATURE DURING FIRE SCENARIO: 95ºC. NOTE 10
SA-JER-DS011-TRJR-480220
10"
LFL
011
021301
101CH2F
SA-JER-DS011-TRJR-480050
20"-LFL-011019302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO:95ºC. MAX. TEMPERATURE FOR OTHER CASES: 100ºC.NOTE 10
SA-JER-DS011-TRJR-480050
3"
LFL
011
021302
101CH2F
3"-NAP-011021004-101CH2S-N
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3"
LFL
011
021302
101CH2F
SA-JER-DS011-TRJR-480050
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
Page 105 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
SA-JER-DS011-TRJR-480050
3/4"
LFL
011
021303
101CH2F 3/4"-NAP-011021018-101CH2S-N
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
021303
101CH2F
SA-JER-DS011-TRJR-480050
3/4"
LFL
011
021304
101CH2F 3/4"-NAP-011021019-101CH2S-N
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
021304
101CH2F
SA-JER-DS011-TRJR-480050
3/4"
LFL
011
021305
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
SA-JER-DS011-TRJR-480050
3/4"
LFL
SA-JER-DS011-TRJR-480220
3/4"
SA-JER-DS011-TRJR-480050
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
SA-JER-DS011-TRJR-480220
-
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
20"-LFL-011019302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480050
3/4"-LFL-011021303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
101CH2F
3/4"-NAP-011021024-101CH2S-S
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
021305
101CH2F
SA-JER-DS011-TRJR-480050
3/4"-LFL-011021306-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
011
021306
101CH2F 3/4"-NAP-011021025-101CH2S-N
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
LFL
011
021306
101CH2F
SA-JER-DS011-TRJR-480050
20"-LFL-011019302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
8"
LFL
011
021307
101CH2F
011-PZV-0015
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE FOR OTHER CASE:100ºC. MAX.TEMPERATURE DURING FIRE SCENARIO: 95ºC. NOTE 10
SA-JER-DS011-TRJR-480050
10"
LFL
011
021307
101CH2F
Reducer
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE FOR OTHER CASE:100ºC. MAX.TEMPERATURE DURING FIRE SCENARIO: 95ºC. NOTE 10
SA-JER-DS011-TRJR-480220
10"
LFL
011
021307
101CH2F
SA-JER-DS011-TRJR-480050
20"-LFL-011019302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO:95ºC. MAX. TEMPERATURE FOR OTHER CASES: 100ºC.NOTE 10
SA-JER-DS011-TRJR-480050
3/4"
LFL
011
021308
101CH2F 3/4"-NAP-011021005-101CH2S-N
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE FOR OTHER CASE:100ºC. MAX.TEMPERATURE DURING FIRE SCENARIO: 95ºC. NOTE 10
SA-JER-DS011-TRJR-480050
3/4"
LFL
011
021308
101CH2F 3/4"-NAP-011021005-101CH2S-N 3/4"-LFL-011021308-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE FOR OTHER CASE:100ºC. MAX.TEMPERATURE DURING FIRE SCENARIO: 95ºC. NOTE 10
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
021308
101CH2F
SA-JER-DS011-TRJR-480050
20"-LFL-011019302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
3/4"
LFL
011
022301
101CH2F
3/4"-JET-011022023-103CS1P-P
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
022301
101CH2F
SA-JER-DS011-TRJR-480052
2"-LFL-011024301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480054
3/4"
LFL
011
023301
101CH2F
3/4"-DIE-011023016-101CS1P-P
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
023301
101CH2F
SA-JER-DS011-TRJR-480054
2"-LFL-011024301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
2"
LFL
011
024301
101CH2F
Cap
36"-LFL-011076303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480056
3/4"
LFL
011
024302
101CH2F
3/4"-HFO-011024012-101CL2P-P
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
024302
101CH2F
SA-JER-DS011-TRJR-480056
2"-LFL-011024301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480059
3/4"
LFL
011
025301
101CH2F
3/4"-DIE-011025013-103CS1P-P
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
3/4"
LFL
011
025301
101CH2F
SA-JER-DS011-TRJR-480059
44"-LFL-011076301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480061
3/4"
LFL
011
025303
101CH2F 3/4"-HFO-011025011-103CS1P-P
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
3/4"
LFL
011
025303
101CH2F
SA-JER-DS011-TRJR-480061
3/4"-LFL-011025301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480062
3"
LFL
011
025304
101CH2F
011-PZV-0068-B
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 50 ºC. NOTE 10
SA-JER-DS011-TRJR-480062
4"
LFL
011
025304
101CH2F
Reducer
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 50 ºC. NOTE 10
SA-JER-DS011-TRJR-480218
4"
LFL
011
025304
101CH2F
SA-JER-DS011-TRJR-480062
44"-LFL-011076301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480062
3"
LFL
011
025304
101CH2F
011-PZV-0068-A
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 50 ºC. NOTE 10
SA-JER-DS011-TRJR-480062
4"
LFL
011
025304
101CH2F
Reducer
4"-LFL-011025304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480062
4"
LFL
011
025304
101CH2F
2"-HFO-011025004-103CS1P-N
4"-LFL-011025304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480050
MAX. TEMPERATURE FOR OTHER CASES: 50 ºC. NOTE 10 MAX. TEMPERATURE FOR OTHER CASES: 50 ºC. NOTE 10
SA-JER-DS011-TRJR-480080
26"
LFL
011
030301
101CH2F
HEADER
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480080
2"
LFL
011
030301
101CH2F
2"-PRO-011030003-101CH4S-P
26"-LFL-011030301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480080
1"
LFL
011
030301
101CH2F
1"-PRO-011030003-101CH4S-P
26"-LFL-011030301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480080
1"
LFL
011
030301
101CH2F
1"-PRO-011030003-101CH4S-P
26"-LFL-011030301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480080
1"
LFL
011
030301
101CH2F
1"-PRO-011030003-101CH4S-P
26"-LFL-011030301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480080
1"
LFL
011
030301
101CH2F
1"-PRO-011030003-101CH4S-P
26"-LFL-011030301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480080
10"
LFL
011
030301
101CH2F
011-PZV-0020
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480220
26"
LFL
011
030301
101CH2F
SA-JER-DS011-TRJR-480080
36"-LFL-011076303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480080
14"
LFL
011
030301
101CH2F
Reducer
26"-LFL-011030301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480080
10"
LFL
011
030301
101CH2F
011-PZV-0019-A
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480080
14"
LFL
011
030301
101CH2F
Reducer
26"-LFL-011030301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480080
10"
LFL
011
030301
101CH2F
011-PZV-0019-B
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480080
14"
LFL
011
030301
101CH2F
Reducer
26"-LFL-011030301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480080
8"
LFL
011
030301
101CH2F
011-PZV-0019-C
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480080
14"
LFL
011
030301
101CH2F
Reducer
26"-LFL-011030301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480081
3/4"
LFL
011
030302
101CH2F 3/4"-HFO-011030009-101SD0P-S
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10 MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10 MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10 MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10 MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10 MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10 MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10 MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390ºC. NOTE 10 MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10 MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10 MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10 MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10 MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10 MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10 MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10 -
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
030302
101CH2F
SA-JER-DS011-TRJR-480081
1"-LFL-011030303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480081
1"
LFL
011
030303
101CH2F
1"-HFO-011030110-101CL4P-S
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480081
1"
LFL
011
030303
101CH2F
1"-HFO-011030112-101CL4P-S
1"-LFL-011030303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
1"
LFL
011
030303
101CH2F
SA-JER-DS011-TRJR-480081
26"-LFL-011030301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480080
3/4"
LFL
011
030304
101CH2F
3/4"-DIE-011030006-101CS1P-P
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
030304
101CH2F
SA-JER-DS011-TRJR-480080
1"-LFL-011030303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480080
3/4"
LFL
011
030305
101CH2F
3/4"-HFO-011030010-101CL2P-P
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
030305
101CH2F
SA-JER-DS011-TRJR-480080
1"-LFL-011030303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
1"
LFL
011
032302
101CH2F
1"-PRO-011032022-101CH4S-P
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
1"
LFL
011
032302
101CH2F
SA-JER-DS011-TRJR-480084
1"-LFL-011034301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480086
8"
LFL
011
033301
101CH2F
011-PZV-0024
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480086
10"
LFL
011
033301
101CH2F
Reducer
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480221
10"
LFL
011
033301
101CH2F
SA-JER-DS011-TRJR-480086
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480086
2"
LFL
011
033301
101CH2F
2"-GAS-011033002-101CH4S-N
10"-LFL-011033301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480086
1"
LFL
011
033302
101CH2F
1"-AWS-011033301-101CH4S-N
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10 -
SA-JER-DS011-TRJR-480221
1"
LFL
011
033302
101CH2F
SA-JER-DS011-TRJR-480086
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480086
3/4"
LFL
011
033303
101CH2F
3/4"-AWS-011033302-101CH2SN
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
3/4"
LFL
011
033303
101CH2F
SA-JER-DS011-TRJR-480086
1"-LFL-011034305-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480087
2"
LFL
011
033304
101CH2F
011-PZV-0086
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480087
3"
LFL
011
033304
101CH2F
Reducer
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480221
3"
LFL
011
033304
101CH2F
SA-JER-DS011-TRJR-480087
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480221
3"
LFL
011
033305
101CH2F
SA-JER-DS011-TRJR-480087
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480087
2"
LFL
011
033305
101CH2F
011-PZV-0087
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480087
3"
LFL
011
033305
101CH2F
Reducer
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480087
2"
LFL
011
033305
101CH2F
2"-PRO-011033025-103CH2S-N
3"-LFL-011033305-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480086
1"
LFL
011
033306
101CH2F
1"-GAS-011033002-101CH4S-N
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480086
3/4"
LFL
011
033306
101CH2F
1"-GAS-011033002-101CH4S-N
1"-LFL-011033306-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480221
1"
LFL
011
033306
101CH2F
SA-JER-DS011-TRJR-480086
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480086
8"
LFL
011
033307
101CH2F
011-PZV-0025
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480086
10"
LFL
011
033307
101CH2F
Reducer
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480221
10"
LFL
011
033307
101CH2F
SA-JER-DS011-TRJR-480086
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480090
1"
LFL
011
034301
101CH2F
1"-GAS-011034007-101CH4S-S
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
-
MAX. TEMPERATURE FOR BACKFLOW: 50ºC NOTE 10 MAX. TEMPERATURE FOR BACKFLOW: 50ºC NOTE 10 MAX. TEMPERATURE FOR BACKFLOW: 50ºC NOTE 10 MAX. TEMPERATURE FOR BACKFLOW: 50ºC NOTE 10 MAX. TEMPERATURE FOR BACKFLOW: 50ºC NOTE 10 MAX. TEMPERATURE FOR BACKFLOW: 50ºC NOTE 10 MAX. TEMPERATURE FOR BACKFLOW: 50ºC NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10 -
Page 106 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480221
1"
LFL
011
034301
101CH2F
SA-JER-DS011-TRJR-480090
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480090
3"
LFL
011
034302
101CH2F
011-PZV-0048
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480090
6"
LFL
011
034302
101CH2F
Reducer
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480221
6"
LFL
011
034302
101CH2F
SA-JER-DS011-TRJR-480090
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480090
1"
LFL
011
034305
101CH2F
1"-GAS-011034012-101CH4S-N
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10 -
SA-JER-DS011-TRJR-480221
1"
LFL
011
034305
101CH2F
SA-JER-DS011-TRJR-480090
1"-LFL-011033302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480089
1"
LFL
011
034306
101CH2F
1"-GAS-011034013-101CH4S-N
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
1"
LFL
011
034306
101CH2F
SA-JER-DS011-TRJR-480089
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 425ºC.
SA-JER-DS011-TRJR-480090
3"
LFL
011
034307
101CH2F
011-PZV-0055
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480090
6"
LFL
011
034307
101CH2F
Reducer
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480221
6"
LFL
011
034307
101CH2F
SA-JER-DS011-TRJR-480090
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480090
2"
LFL
011
034307
101CH2F
2"-GAS-011034003-101CH4S-N
6"-LFL-011034307-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480091
3"
LFL
011
035301
101CH2F
011-PZV-0550
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
SA-JER-DS011-TRJR-480091
6"
LFL
011
035301
101CH2F
Reducer
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER RELIEF CASES 140° C
SA-JER-DS011-TRJR-480221
6"
LFL
011
035301
101CH2F
SA-JER-DS011-TRJR-480091
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480091
2"
LFL
011
035302
101CH2F
2"-GAS-011035406-101CH4S-P
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
2"
LFL
011
035302
101CH2F
SA-JER-DS011-TRJR-480091
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480091
4"
LFL
011
035303
101CH2F
4"-GAS-011035003-101CH4S-P
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
NOTE 10.
SA-JER-DS011-TRJR-480221
4"
LFL
011
035303
101CH2F
SA-JER-DS011-TRJR-480091
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
NOTE 10.
SA-JER-DS011-TRJR-480091
3"
LFL
011
035304
101CH2F
011-PZV-0551
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
NOTE 10.
SA-JER-DS011-TRJR-480091
6"
LFL
011
035304
101CH2F
Reducer
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
NOTE 10.
SA-JER-DS011-TRJR-480221
6"
LFL
011
035304
101CH2F
SA-JER-DS011-TRJR-480091
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
NOTE 10.
SA-JER-DS011-TRJR-480264
1"
LFL
011
035305
101CH2F
TP-17
1"-LFL-011035305-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
5.00
-0.50
170.00
120.00
-
H
7.50
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480264
1"
LFL
011
035305
101CH2F
1"-LFL-011035305-101CH2F-N
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
1"
LFL
011
035305
101CH2F
SA-JER-DS011-TRJR-480264
2"-LFL-011035302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480264
1"
LFL
011
035306
101CH2F
TP-18
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
1"
LFL
011
035306
101CH2F
SA-JER-DS011-TRJR-480264
2"-LFL-011035302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480091
2"
LFL
011
035309
101CH2F
2"-GAS-011035408-101CH4S-S
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480221
2"
LFL
011
035309
101CH2F
SA-JER-DS011-TRJR-480091
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
-
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 160°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 160°C NOTE 10
SA-JER-DS011-TRJR-480094
3"
LFL
011
036301
101CH2F
SA-JER-DS011-TRJR-480094
4"
LFL
011
036301
101CH2F
SA-JER-DS011-TRJR-480221
4"
LFL
011
036301
101CH2F
SA-JER-DS011-TRJR-480094
3"
LFL
011
036301
101CH2F
SA-JER-DS011-TRJR-480094
4"
LFL
011
036301
SA-JER-DS011-TRJR-480094
2"
LFL
011
SA-JER-DS011-TRJR-480094
1"
LFL
SA-JER-DS011-TRJR-480221
1"
LFL
SA-JER-DS011-TRJR-480094
4"
LFL
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
Reducer
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480094
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
-
011-PZV-0033
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 160°C NOTE 10
101CH2F
Reducer
4"-LFL-011036301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 160°C NOTE 10
036301
101CH2F
2"-GAS-011036007-101CH4S-P
4"-LFL-011036301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 160°C NOTE 10
011
036303
101CH2F
1"-GAS-011036011-101CH4S-S
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
011
036303
101CH2F
SA-JER-DS011-TRJR-480094
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
011
036304
101CH2F
011-ZV-0029
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
4"
LFL
011
036304
101CH2F
SA-JER-DS011-TRJR-480094
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480094 SA-JER-DS011-TRJR-480221
1"
LFL
011
036306
101CH2F
1"-AMI-011036301-101CH4S-P
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
1"
LFL
011
036306
101CH2F
SA-JER-DS011-TRJR-480094
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480093
1"
LFL
011
036307
101CH2F
1"-GAS-011036008-101CH4S-N
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480221
1"
LFL
011
036307
101CH2F
SA-JER-DS011-TRJR-480093
1"-LFL-011034301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480098
3"
LFL
011
037301
101CH2F
SA-JER-DS011-TRJR-480098
4"
LFL
011
037301
101CH2F
SA-JER-DS011-TRJR-480218
4"
LFL
011
037301
101CH2F
SA-JER-DS011-TRJR-480098
3"
LFL
011
037301
101CH2F
SA-JER-DS011-TRJR-480098
4"
LFL
011
037301
SA-JER-DS011-TRJR-480098
4"
LFL
011
SA-JER-DS011-TRJR-480097
2"
LFL
SA-JER-DS011-TRJR-480218
2"
SA-JER-DS011-TRJR-480102
Y
N
N
N
N
N
N
N
N
N
-
-
A or Q
Y
MAX. TEMPERATURE BY COMPRESSOR VENDOR. NOTE 10
-
YES
A or Q
MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10
Reducer
011-PZV-0034
YES
-
N
-
-
MAX. TEMPERATURE FOR OTHER CASES: 50°C NOTE 10 MAX. TEMPERATURE FOR OTHER CASES: 50°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 200ºC. MAX. TEMPERATURE FOR OTHER CASES: 145°C NOTE 10 MAX. TEMPERATURE FOR OTHER CASES: 50°C NOTE 10 MAX. TEMPERATURE FOR OTHER CASES: 50°C NOTE 10 MAX. TEMPERATURE FOR OTHER CASES: 50°C NOTE 10 -
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
Reducer
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480098
44"-LFL-011076301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
011-PZV-0069-A
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
101CH2F
Reducer
4"-LFL-011037301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
037301
101CH2F
2"-DIE-011037016-103CS1P-N
4"-LFL-011037301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
011
037302
101CH2F
2"-DIE-011037021-103CS1P-P
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
LFL
011
037302
101CH2F
SA-JER-DS011-TRJR-480097
8"-LFL-011005301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
2"
LFL
011
039301
101CH2F
011-PZV-0070
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480102
3"
LFL
011
039301
101CH2F
Reducer
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480221
3"
LFL
011
039301
101CH2F
SA-JER-DS011-TRJR-480102
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480102
2"
LFL
011
039301
101CH2F
2"-HFO-011039014-103SD0P-S
3"-LFL-011039301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480112
2"
LFL
011
043301
101CH2F
2"-PRW-011043001-101CS1P-N
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 425ºC NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 425ºC NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 425ºC NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 425ºC NOTE 10 -
SA-JER-DS011-TRJR-480112
3"
LFL
011
043301
101CH2F
Reducer
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
3"
LFL
011
043301
101CH2F
SA-JER-DS011-TRJR-480112
44"-LFL-011076301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480218
12"
LFL
011
043302
101CH2F
SA-JER-DS011-TRJR-480112
44"-LFL-011076301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
011-PZV-0069-B
-
-
011-PZV-0050
Reducer
-
-
N
-
FUEL GAS
Liquid
991
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 155 ºC. MAX TEMPERATURE FOR OTHER CASES: 150 ºC. NOTE 10.
101CH2F
Reducer
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Liquid
991
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 155 ºC. MAX TEMPERATURE FOR OTHER CASES: 150 ºC. NOTE 10.
101CH2F
3/4"-PRW-011043002-101CS1PN
12"-LFL-011043302-101CH2F-N
-
-
N
-
FUEL GAS
Liquid
991
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480112
8"
LFL
011
043302
101CH2F
SA-JER-DS011-TRJR-480112
12"
LFL
011
043302
SA-JER-DS011-TRJR-480112
3/4"
LFL
011
043302
101CH2F
3/4"-PRW-011043002-101CS1PN
3/4"-LFL-011043302-101CH2F-N
-
-
N
-
FUEL GAS
Liquid
991
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 155 ºC. MAX TEMPERATURE FOR OTHER CASES: 150 ºC. NOTE 10. MAX.TEMPERATURE DURING FIRE SCENARIO: 155 ºC. MAX TEMPERATURE FOR OTHER CASES: 150 ºC. NOTE 10.
SA-JER-DS011-TRJR-480112
8"
LFL
011
043303
101CH2F
011-PZV-0049
Reducer
-
-
N
-
FUEL GAS
Liquid
991
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 155 ºC. MAX TEMPERATURE FOR OTHER CASES: 150 ºC. NOTE 10.
SA-JER-DS011-TRJR-480112
12"
LFL
011
043303
101CH2F
Reducer
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Liquid
991
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 155 ºC. MAX TEMPERATURE FOR OTHER CASES: 150 ºC. NOTE 10.
SA-JER-DS011-TRJR-480218
12"
LFL
011
043303
101CH2F
SA-JER-DS011-TRJR-480112
44"-LFL-011076301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480113
3/4"
LFL
011
044301
101CH2F
3/4"-AWS-011044013-101CH2SP
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
044301
101CH2F
SA-JER-DS011-TRJR-480113
3/4"-LFL-011021303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
3"
LFL
011
075301
101CH2F
011-PZV-0044-A
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 175ºC.
SA-JER-DS011-TRJR-480214
4"
LFL
011
075301
101CH2F
Reducer
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 175ºC.
SA-JER-DS011-TRJR-480220
4"
LFL
011
075301
101CH2F
SA-JER-DS011-TRJR-480214
36"-LFL-011076303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 175ºC.
SA-JER-DS011-TRJR-480214
3"
LFL
011
075301
101CH2F
011-PZV-0044-B
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 175ºC.
SA-JER-DS011-TRJR-480214
4"
LFL
011
075301
101CH2F
Reducer
4"-LFL-011075301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 175ºC.
SA-JER-DS011-TRJR-480214
2"
LFL
011
075301
101CH2F
2"-FGS-011075304-101CS2P-N
4"-LFL-011075301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 175ºC.
SA-JER-DS011-TRJR-480214
2"
LFL
011
075302
101CH2F
2"-FGS-011075308-101CS2P-N
SA-JER-DS011-TRJR-480219
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480219
2"
LFL
011
075302
101CH2F
SA-JER-DS011-TRJR-480214
44"-LFL-011076001-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
3/4"
SA-JER-DS011-TRJR-380001
LFL
011
043302
MAX. TEMPERATURE FOR OTHER CASES: 50 °C NOTE 10 -
Page 107 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
FLUID
THICKNESS (mm)
PHASE
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480214
2"
LFL
011
075303
101CH2F
2"-PTG-011075305-101CS1P-S
SA-JER-DS011-TRJR-480219
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480219
2"
LFL
011
075303
101CH2F
SA-JER-DS011-TRJR-480214
44"-LFL-011076001-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
2"
LFL
011
075304
101CH2F
2"-FGS-011075305-101CS2P-S
SA-JER-DS011-TRJR-480220
S
37
H
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
2"
LFL
011
075304
101CH2F
SA-JER-DS011-TRJR-480214
36"-LFL-011076303-101CH2F-N
S
37
H
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
3/4"
LFL
011
075305
101CH2F 3/4"-FGS-011075310-101CS2P-N
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
075305
101CH2F
SA-JER-DS011-TRJR-480214
2"-LFL-011075304-101CH2F-S
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
3/4"
LFL
011
075306
101CH2F
3/4"-FGS-011075306-101CS2P-S
SA-JER-DS011-TRJR-480220
S
37
H
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
075306
101CH2F
SA-JER-DS011-TRJR-480214
2"-LFL-011075304-101CH2F-S
S
37
H
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
2"
LFL
011
075307
101CH2F
2"-PTG-011075303-101CS1P-S
SA-JER-DS011-TRJR-480220
S
37
H
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
3/4"
LFL
011
075307
101CH2F
3/4"-PTG-011075308-101CS1P-S
2"-LFL-011075307-101CH2F-S
S
37
H
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
2"
LFL
011
075307
101CH2F
SA-JER-DS011-TRJR-480214
36"-LFL-011076303-101CH2F-N
S
37
H
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480219
44"
LFL
011
076001
101CH2F
011-D-0018
IP-1331L
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
M
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
24"
LFL
011
076301
101CH2F
HEADER
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
44"
LFL
011
076301
101CH2F
Reducer
SA-JER-DS011-TRJR-480219
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
M
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480219
44"
LFL
011
076301
101CH2F
SA-JER-DS011-TRJR-480218
N
-
-
SA-JER-DS011-TRJR-480219
44"
LFL
011
076301
101CH2F
44"-LFL-011076301-101CH2F-N
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
M
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480219
32"
LFL
011
076301
101CH2F
Reducer
011-D-0018
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
M
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480219
32"
LFL
011
076301
101CH2F
Reducer
011-D-0018
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
M
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480219
3/4"
LFL
011
076302
101CH2F
011-LG-0087
32"-LFL-011076301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
36"
LFL
011
076303
101CH2F
HEADER
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
M
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
36"
LFL
011
076303
101CH2F
SA-JER-DS011-TRJR-480221
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
M
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
42"
LFL
011
076303
101CH2F
Reducer
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
M
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
42"
LFL
011
076303
101CH2F
SA-JER-DS011-TRJR-480220
44"-LFL-011076301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
M
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
12"
LFL
011
076304
101CH2F
HEADER
36"-LFL-011076303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
2"
LFL
011
076305
101CH2F
2"-FGS-011076301-101CS2P-H
24"-LFL-011076301-101CH2F-N
-
-
H
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
1"
LFL
011
076305
101CH2F
2"-LFL-011076305-101CH2F-H
Blind flange
-
-
H
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
2"
LFL
011
076305
101CH2F
2"-N2L-011076301-101CS1P-N
Insul Brk
-
-
P
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
3/4"
LFL
011
076305
101CH2F
2"-LFL-011076305-101CH2F-P
Blind flange
-
-
P
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
2"
LFL
011
076305
101CH2F
Insul Brk
2"-LFL-011076305-101CH2F-H
-
-
H
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M or Q
Y
N
N
N
N
N
-
-
Reducer
-
INSULATION (NOTE 2)
DOC. No.
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
PNEU
3.85
M
YES
A or Q
Y
N
N
N
N
SA-JER-DS011-TRJR-480221
2"
LFL
011
076306
101CH2F
2"-FGS-011076302-101CS2P-H
12"-LFL-011076304-101CH2F-N
-
-
H
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
3/4"
LFL
011
076306
101CH2F
2"-LFL-011076306-101CH2F-P
Blind flange
-
-
H
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
2"
LFL
011
076306
101CH2F
Insul Brk
2"-LFL-011076306-101CH2F-H
-
-
H
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
1"
LFL
011
076306
101CH2F
2"-LFL-011076306-101CH2F-H
Blind flange
-
-
H
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
2"
LFL
011
076306
101CH2F
2"-N2L-011076302-101CS1P-N
Insul Brk
-
-
H
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
2"
LFL
011
076307
101CH2F
2"-FGS-011076303-101CS2P-H
36"-LFL-011076303-101CH2F-N
-
-
H
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
2"
LFL
011
076307
101CH2F
2"-N2L-011076303-101CS1P-N
Insul Brk
-
-
H
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
1"
LFL
011
076307
101CH2F
2"-LFL-011076307-101CH2F-H
Blind flange
-
-
H
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
2"
LFL
011
076307
101CH2F
Insul Brk
2"-LFL-011076307-101CH2F-H
-
-
H
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
3/4"
LFL
011
076307
101CH2F
2"-LFL-011076307-101CH2F-P
Blind flange
-
-
H
25
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
M or Q
Y
N
N
N
N
N
-
-
Y
N
N
N
N
N
-
STEAM OUT CONDITION: 0,5 BARA (HALF VACUUM) @ 150ºC
Y
N
N
N
N
N
-
STEAM OUT CONDITION: 0,5 BARA (HALF VACUUM) @ 150ºC
-
if insulated M or Q SA-JER-DS011-TRJR-480219
-
LFL
011
076601
101CH2S
011-D-0018
TRIM
-
-
H
-
-
-
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
Visual Test
0.00
M
YES
SA-JER-DS011-TRJR-480219
4"
LFL
011
076601
101CH2S
011-D-0018
Blind flange
-
-
H
25
-
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
SA-JER-DS011-TRJR-480232
6"
LFL
011
078301
101CH2F
011-D-0014
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480218
6"
LFL
011
078301
101CH2F
SA-JER-DS011-TRJR-480232
44"-LFL-011076301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480233
4"
LFL
011
079301
101CH2F
011-D-0025
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 bara @ 150ºC.
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
SA-JER-DS011-TRJR-480221
4"
LFL
011
079301
101CH2F
SA-JER-DS011-TRJR-480233
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 220°C. NOTE 10
SA-JER-DS011-TRJR-480233
3/4"
LFL
011
079302
101CH2F
3/4"-AMD-011079008-101CH2SP
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 bara @ 150ºC.
SA-JER-DS011-TRJR-480221
3/4"
LFL
011
079302
101CH2F
SA-JER-DS011-TRJR-480233
12"-LFL-011076304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
Y
N
N
Y
N
N
-
STEAM OUT CONDITIONS: 0.5 bara @ 150ºC.
Y
N
N
Y
N
N
-
STEAM OUT CONDITIONS: 0.5 bara @ 150ºC.
Y
N
N
Y
N
N
-
STEAM OUT CONDITIONS: 0.5 bara @ 150ºC.
Y
N
N
Y
N
N
-
STEAM OUT CONDITIONS: 0.5 bara @ 150ºC.
Y
N
N
Y
N
N
-
STEAM OUT CONDITIONS: 0.5 bara @ 150ºC.
Y
N
N
Y
N
N
-
STEAM OUT CONDITIONS: 0.5 bara @ 150ºC.
Y
N
N
Y
N
N
-
STEAM OUT CONDITIONS: 0.5 bara @ 150ºC.
if insulated M or Q SA-JER-DS011-TRJR-480233
-
LFL
011
079601
101CH2F
011-D-0025
TRIM
-
-
P
-
-
-
-
0.30
71.00
-
-
3.50
-0.50
100.00
120.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480233
2"
LFL
011
079601
101CH2F
011-D-0025
011-LT-0133
-
-
P
25
-
-
-
0.30
71.00
-
-
3.50
-0.50
100.00
120.00
-
H
5.25
NFS
YES
SA-JER-DS011-TRJR-480233
2"
LFL
011
079601
101CH2F
011-D-0025
011-LT-0133
-
-
P
25
-
-
-
0.30
71.00
-
-
3.50
-0.50
100.00
120.00
-
H
5.25
NFS
YES
SA-JER-DS011-TRJR-480233
2"
LFL
011
079601
101CH2F
011-D-0025
Blind flange
-
-
P
25
-
-
-
0.30
71.00
-
-
3.50
-0.50
100.00
120.00
-
H
5.25
NFS
YES
SA-JER-DS011-TRJR-480233
2"
LFL
011
079601
101CH2F
011-D-0025
011-LG-0134
-
-
P
25
-
-
-
0.30
71.00
-
-
3.50
-0.50
100.00
120.00
-
H
5.25
NFS
YES
SA-JER-DS011-TRJR-480233
6"
LFL
011
079601
101CH2F
011-D-0025
Blind flange
-
-
P
25
-
-
-
0.30
71.00
-
-
3.50
-0.50
100.00
120.00
-
H
5.25
NFS
YES
SA-JER-DS011-TRJR-480233
2"
LFL
011
079601
101CH2F
011-D-0025
011-LG-0134
-
-
P
25
-
-
-
0.30
71.00
-
-
3.50
-0.50
100.00
120.00
-
H
5.25
NFS
YES
SA-JER-DS011-TRJR-480225
2"
LFL
011
099301
101CH2F
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0,50
120.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480225
3"
LFL
011
099301
101CH2F
Reducer
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0,50
120.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
3"
LFL
011
099301
101CH2F
SA-JER-DS011-TRJR-480225
8"-LFL-011001301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0,50
120.00
-
H
5.25
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480246
3/4"
LFL
011
171305
101CH2F
011-G-0010-A
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
171305
101CH2F
SA-JER-DS011-TRJR-480246
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
1"
LFL
011
171305
101CH2F
Reducer
36"-LFL-011076303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480246
3/4"
LFL
011
171306
101CH2F
011-G-0010-B
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
171306
101CH2F
SA-JER-DS011-TRJR-480246
3/4"-LFL-011171305-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480246
3/4"
LFL
011
171315
101CH2F
011-G-0010-A
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
171315
101CH2F
SA-JER-DS011-TRJR-480246
3/4"-LFL-011171305-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480246
3/4"
LFL
011
171316
101CH2F
011-G-0010-B
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
011-PZV-0093
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
Page 108 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
171316
101CH2F
SA-JER-DS011-TRJR-480246
3/4"-LFL-011171305-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480263
3/4"
LFL
011
171317
101CH2F
011-G-0012-A
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
171317
101CH2F
SA-JER-DS011-TRJR-480263
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
1"
LFL
011
171317
101CH2F
Reducer
36"-LFL-011076303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480263
3/4"
LFL
011
171318
101CH2F
011-G-0012-B
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
171318
101CH2F
SA-JER-DS011-TRJR-480263
1"-LFL-011171317-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480263
3/4"
LFL
011
171319
101CH2F
011-G-0012-A
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
171319
101CH2F
SA-JER-DS011-TRJR-480263
3/4"-LFL-011171317-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480263
3/4"
LFL
011
171320
101CH2F
011-G-0012-B
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
171320
101CH2F
SA-JER-DS011-TRJR-480263
3/4"-LFL-011171318-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480247
3/4"
LFL
011
171331
101CH2F
011-G-0016-A
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
3/4"
LFL
011
171331
101CH2F
SA-JER-DS011-TRJR-480247
36"-LFL-011076303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480247
3/4"
LFL
011
171332
101CH2F
011-G-0016-B
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
3/4"
LFL
011
171332
101CH2F
SA-JER-DS011-TRJR-480247
3/4"-LFL-011171331-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
3/4"
LFL
011
171354
101CH2F
011-G-0011-A
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
171354
101CH2F
SA-JER-DS011-TRJR-480250
3/4"-LFL-011171355-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
3/4"
LFL
011
171355
101CH2F
011-G-0011-B
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
171355
101CH2F
SA-JER-DS011-TRJR-480250
3/4"-LFL-011171357-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
3/4"
LFL
011
171356
101CH2F
011-G-0013-A
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
171356
101CH2F
SA-JER-DS011-TRJR-480250
3/4"-LFL-011171357-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
3/4"
LFL
011
171357
101CH2F
011-G-0013-B
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
171357
101CH2F
SA-JER-DS011-TRJR-480250
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
1"
LFL
011
171357
101CH2F
Reducer
20"-LFL-011019302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480253
3/4"
LFL
011
171361
101CH2F
011-G-0015-A
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
3/4"
LFL
011
171361
101CH2F
SA-JER-DS011-TRJR-480253
3/4"-LFL-011171363-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480253
3/4"
LFL
011
171362
101CH2F
011-G-0015-A
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
3/4"
LFL
011
171362
101CH2F
SA-JER-DS011-TRJR-480253
3/4"-LFL-011171361-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480253
3/4"
LFL
011
171363
101CH2F
011-G-0015-B
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
3/4"
LFL
011
171363
101CH2F
SA-JER-DS011-TRJR-480253
3/4"-LFL-011171331-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480253
3/4"
LFL
011
171364
101CH2F
011-G-0015-B
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
3/4"
LFL
011
171364
101CH2F
SA-JER-DS011-TRJR-480253
3/4"-LFL-011171363-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480251
1/2"
LFL
011
171365
101CH2F
011-G-0003-A
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480251
3/4"
LFL
011
171365
101CH2F
Reducer
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
3/4"
LFL
011
171365
101CH2F
SA-JER-DS011-TRJR-480251
24"-LFL-011076301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480251
1/2"
LFL
011
171366
101CH2F
011-G-0003-B
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480251
3/4"
LFL
011
171366
101CH2F
Reducer
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
3/4"
LFL
011
171366
101CH2F
SA-JER-DS011-TRJR-480251
3/4"-LFL-011171365-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
3/4"
LFL
011
200303
101CH2F 3/4"-GAS-011200002-101CH4S-P
SA-JER-DS011-TRJR-480221
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
M
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
3/4"
LFL
011
200303
101CH2F
SA-JER-DS011-TRJR-480274
2"-LFL-011035302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480274
3/4"
LFL
011
200304
101CH2F
3/4"-NAP-011200002-101CH2S-P
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
14"-LFL-011012301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
3/4"-FGS-011200301-101CS2P-S
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 145ºC. MAX. TEMPERATURE FOR OTHER CASES: 110°C NOTE 10 -
SA-JER-DS011-TRJR-480274
2"-LFL-011075304-101CH2F-S
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
3/4"-NAP-011019020-101CH2S-P
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
101CH2F
SA-JER-DS011-TRJR-480275
3/4"-LFL-011200308-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
3/4"-CWS-011012003-101CH2SP
SA-JER-DS011-TRJR-480218
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
3/4"
LFL
011
200304
101CH2F
SA-JER-DS011-TRJR-480274
SA-JER-DS011-TRJR-480274
3/4"
LFL
011
200305
101CH2F
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
200305
101CH2F
SA-JER-DS011-TRJR-480275
3/4"
LFL
011
200306
101CH2F
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
200306
SA-JER-DS011-TRJR-480275
3/4"
LFL
011
200307
101CH2F
SA-JER-DS011-TRJR-480218
3/4"
LFL
011
200307
101CH2F
SA-JER-DS011-TRJR-480275
3/4"-LFL-011200304-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480275
3/4"
LFL
011
200308
101CH2F
3/4"-CWS-011019008-101CH2SP
SA-JER-DS011-TRJR-480220
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480220
3/4"
LFL
011
200308
101CH2F
SA-JER-DS011-TRJR-480275
20"-LFL-011019302-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
3/4"
LFL
011
200309
101CH2F 3/4"-NAP-011200001-103CH2S-N
SA-JER-DS011-TRJR-480219
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480219
3/4"
LFL
011
200309
101CH2F
SA-JER-DS011-TRJR-480274
2"-LFL-011075303-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480273
1"
LFL
011
200310
101CH2F
1"-GAS-011036013-101CH4S-S
SA-JER-DS011-TRJR-480094
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480094
1"
LFL
011
200310
101CH2F
SA-JER-DS011-TRJR-480273
Reducer
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480094
3/4"
LFL
011
200310
101CH2F
Reducer
3/4"-LFL-011036301-101CH2F-N
-
-
N
-
FUEL GAS
Gas
-
0.20
50.00
-
-
3.50
-0.50
350.00
120.00
-
H
6.22
NFS
YES
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
3/4"
LPC
011
040010
101CS1P
2"-ACS-011040001-101CS1P-P
3"-LPS-011040009-101CS1P-P
-
-
P
25
LP CONDENSATE
Gas
-
0.20
107.00
-
-
3.50
-1.00
135.00
135.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480121
3"
LPC
011
051301
101CS1P
3"-LPS-011051302-101CS1P-H
SA-JER-DS011-TRJR-480205
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480121
3"
LPC
011
051301
101CS1P
Reducer
3"-LPC-011051301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480121
1-1/2"
LPC
011
051301
101CS1P
1-1/2"-LPS-011051302-101CS1PH
Reducer
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
3"
LPC
011
051301
101CS1P
SA-JER-DS011-TRJR-480121
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480201
2"
LPC
011
071001
101CS1P
011-A-0008
011-D-0026
-
-
P
25
LP CONDENSATE
Liquid
935
2.00
129.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
2"
LPC
011
071001
101CS1P
2"-LPC-011071001-101CS1P-P
2"-OLW-011071304-101CS1P-N
-
-
P
25
LP CONDENSATE
Liquid
935
2.00
129.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
4"
LPC
011
071002
101CS1P
011-D-0026
4"-CND-011071303-103CS1P-H
-
-
H
50
LP CONDENSATE
Liquid
932
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
4"
LPC
011
071002
101CS1P
4"-LPC-011071002-101CS1P-H
4"-CND-011071304-103CS1P-H
-
-
H
50
LP CONDENSATE
Liquid
932
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
6"
LPC
011
071003
101CS1P
6"-LPC-011071301-101CS1P-H
SA-JER-DS011-TRJR-480201
-
-
H
50
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480201
6"
LPC
011
071003
101CS1P
SA-JER-DS011-TRJR-480202
011-D-0026
-
-
H
50
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480201
2"
LPC
011
071004
101CS1P
011-D-0026
2"-OLW-011071301-101CS1P-N
-
-
H
40
LP CONDENSATE
Liquid
932
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
2"
LPC
011
071005
101CS1P
4"-LPC-011071002-101CS1P-H
Insul Brk
-
-
H
40
LP CONDENSATE
Liquid
932
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
2"
LPC
011
071005
101CS1P
Insul Brk
2"-OLW-011071302-101CS1P-N
-
-
P
25
LP CONDENSATE
Liquid
932
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
2"
LPC
011
071006
101CS1P
4"-LPC-011071002-101CS1P-H
Insul Brk
-
-
H
40
LP CONDENSATE
Liquid
932
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
2"
LPC
011
071006
101CS1P
Insul Brk
2"-OLW-011071303-101CS1P-N
-
-
P
25
LP CONDENSATE
Liquid
932
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
1-1/2"
LPC
011
071007
101CS1P
011-A-0008
Reducer
-
-
P
25
LP CONDENSATE
Liquid
932
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
2"
LPC
011
071007
101CS1P
Reducer
2"-OLW-011071305-101CS1P-N
-
-
P
25
LP CONDENSATE
Liquid
932
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
6"
LPC
011
071301
101CS1P
HEADER
SA-JER-DS011-TRJR-480206
-
-
H
50
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480202
6"
LPC
011
071301
101CS1P
SA-JER-DS011-TRJR-480204
6"-LPC-011071301-101CS1P-H
-
-
H
50
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480204
6"
LPC
011
071301
101CS1P
SA-JER-DS011-TRJR-480313
SA-JER-DS011-TRJR-480202
-
-
H
50
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480313
6"
LPC
011
071301
101CS1P
SA-JER-DS011-TRJR-480205
SA-JER-DS011-TRJR-480204
-
-
H
50
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480206
6"
LPC
011
071301
101CS1P
SA-JER-DS011-TRJR-480202
HEADER
-
-
H
50
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.5
139
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
6"
LPC
011
071301
101CS1P
SA-JER-DS011-TRJR-480203
SA-JER-DS011-TRJR-480313
-
-
H
50
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
6"
LPC
011
071301
101CS1P
HEADER
SA-JER-DS011-TRJR-480205
-
-
H
50
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480201
4"
LPC
011
071303
101CS1P
4"-MPC-011071302-103CS1P-H
011-D-0026
-
-
H
50
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480201
-
LPC
011
071601
103CS1P
011-D-0026
TRIM
-
-
H
-
-
-
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
Visual Test
0.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
2"
LPC
011
071601
103CS1P
011-D-0026
011-PT-0409
-
-
H
40
-
-
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480313
1-1/2"
LPC
011
071701
101CS1P
011-RM-001-LC
Reducer
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480313
2"
LPC
011
071701
101CS1P
Reducer
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480313
1-1/2"
LPC
011
071702
101CS1P
011-RM-002-LC
2"-LPC-011071765-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
LPC
011
071703
101CS1P
011-RM-003-LC
2"-LPC-011071734-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480313
1-1/2"
LPC
011
071705
101CS1P
011-RM-005-LC
2"-LPC-011071701-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
LPC
011
071707
101CS1P
011-RM-007-LC
4"-LPC-011071715-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
LPC
011
071708
101CS1P
011-RM-008-LC
Reducer
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-380001
Page 109 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
INSULATION (NOTE 2)
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480205
2"
LPC
011
071708
101CS1P
Reducer
4"-LPC-011071715-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
LPC
011
071709
101CS1P
011-RM-009-LC
2"-LPC-011071710-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
LPC
011
071710
101CS1P
011-RM-010-LC
Reducer
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
2"
LPC
011
071710
101CS1P
Reducer
4"-LPC-011071715-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
LPC
011
071711
101CS1P
011-RM-011-LC
2"-LPC-011071708-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
1-1/2"
LPC
011
071712
101CS1P
011-RM-012-LC
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
1-1/2"
LPC
011
071714
101CS1P
011-RM-014-LC
Reducer
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
2"
LPC
011
071714
101CS1P
Reducer
2"-LPC-011071735-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
LPC
011
071715
101CS1P
011-RM-015-LC
Reducer
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
2"
LPC
011
071715
101CS1P
Reducer
Reducer
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
4"
LPC
011
071715
101CS1P
Reducer
6"-LPC-011071301-101CS1P-H
-
-
H
50
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
LPC
011
071716
101CS1P
011-RM-016-LC
2"-LPC-011071715-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
LPC
011
071717
101CS1P
011-RM-017-LC
2"-LPC-011071715-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
LPC
011
071719
101CS1P
011-RM-019-LC
Reducer
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
2"
LPC
011
071719
101CS1P
Reducer
4"-LPC-011071715-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
LPC
011
071720
101CS1P
011-RM-020-LC
2"-LPC-011071719-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
1-1/2"
LPC
011
071723
101CS1P
011-RM-023-LC
2"-LPC-011071726-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
1-1/2"
LPC
011
071724
101CS1P
011-RM-024-LC
2"-LPC-011071726-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
1-1/2"
LPC
011
071725
101CS1P
011-RM-025-LC
2"-LPC-011071726-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
1-1/2"
LPC
011
071726
101CS1P
011-RM-026-LC
Reducer
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
2"
LPC
011
071726
101CS1P
Reducer
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
1-1/2"
LPC
011
071727
101CS1P
011-RM-027-LC
2"-LPC-011071730-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
1-1/2"
LPC
011
071728
101CS1P
011-RM-028-LC
2"-LPC-011071730-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
1-1/2"
LPC
011
071729
101CS1P
011-RM-029-LC
2"-LPC-011071730-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
1-1/2"
LPC
011
071730
101CS1P
011-RM-030-LC
Reducer
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
2"
LPC
011
071730
101CS1P
Reducer
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
1-1/2"
LPC
011
071731
101CS1P
011-RM-031-LC
2"-LPC-011071732-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
1-1/2"
LPC
011
071732
101CS1P
011-RM-032-LC
Reducer
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
2"
LPC
011
071732
101CS1P
Reducer
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
LPC
011
071733
101CS1P
011-RM-033-LC
2"-LPC-011071734-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
LPC
011
071734
101CS1P
011-RM-034-LC
Reducer
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
2"
LPC
011
071734
101CS1P
Reducer
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
1-1/2"
LPC
011
071735
101CS1P
011-RM-035-LC
Reducer
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
2"
LPC
011
071735
101CS1P
Reducer
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
1-1/2"
LPC
011
071736
101CS1P
011-RM-036-LC
2"-LPC-011071735-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
LPC
011
071737
101CS1P
011-RM-037-LC
2"-LPC-011071738-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
LPC
011
071738
101CS1P
011-RM-038-LC
Reducer
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
2"
LPC
011
071738
101CS1P
Reducer
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480313
1-1/2"
LPC
011
071739
101CS1P
011-RM-039-LC
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480313
1-1/2"
LPC
011
071741
101CS1P
011-RM-041-LC
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480313
1-1/2"
LPC
011
071742
101CS1P
011-RM-042-LC
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480313
1-1/2"
LPC
011
071743
101CS1P
011-RM-043-LC
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480313
1-1/2"
LPC
011
071744
101CS1P
011-RM-044-LC
2"-LPC-011071765-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480202
1-1/2"
LPC
011
071745
101CS1P
011-RM-045-LC
2"-LPC-011071755-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480206
1-1/2"
LPC
011
071747
101CS1P
011-RM-047-LC
Reducer
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480206
2"
LPC
011
071747
101CS1P
Reducer
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480206
1-1/2"
LPC
011
071749
101CS1P
011-RM-049-LC
2"-LPC-011071747-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480202
1-1/2"
LPC
011
071752
101CS1P
011-RM-052-LC
2"-LPC-011071755-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480202
1-1/2"
LPC
011
071753
101CS1P
011-RM-053-LC
2"-LPC-011071755-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480202
1-1/2"
LPC
011
071754
101CS1P
011-RM-054-LC
2"-LPC-011071755-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480202
2"
LPC
011
071755
101CS1P
HEADER
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480202
1-1/2"
LPC
011
071755
101CS1P
011-RM-055-LC
2"-LPC-011071755-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480202
1-1/2"
LPC
011
071756
101CS1P
011-RM-056-LC
2"-LPC-011071755-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480202
1-1/2"
LPC
011
071758
101CS1P
011-RM-058-LC
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480202
1-1/2"
LPC
011
071759
101CS1P
011-RM-059-LC
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480206
1-1/2"
LPC
011
071761
101CS1P
011-RM-061-LC
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480206
1-1/2"
LPC
011
071762
101CS1P
011-RM-062-LC
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480313
1-1/2"
LPC
011
071764
101CS1P
011-RM-064-LC
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480313
1-1/2"
LPC
011
071765
101CS1P
011-RM-065-LC
Reducer
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480313
2"
LPC
011
071765
101CS1P
Reducer
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
LPC
011
071766
101CS1P
011-RM-066-LC
2"-LPC-011071734-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
1-1/2"
LPC
011
071769
101CS1P
011-RM-069-LC
2"-LPC-011071730-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
1-1/2"
LPC
011
071779
101CS1P
011-RM-070-LC
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
LPC
011
071780
101CS1P
011-RM-071-LC
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
2"-LPS-011076303-101CS1P-H
SA-JER-DS011-TRJR-480202
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
-
H
25
927.1
2.50
139.00
-
-
7.00
1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
1-1/2"-LPC-011071779-101CS1PH 1-1/2"-LPC-011071734-101CS1PH
SA-JER-DS011-TRJR-480219
2"
LPC
011
076301
101CS1P
SA-JER-DS011-TRJR-480219
3/4"
LPC
011
076301
101CS1P
3/4"-LPS-011076303-101CS1P-H
Reducer
-
LP CONDENSATE
Liquid/Gas Mixture
SA-JER-DS011-TRJR-480219
2"
LPC
011
076301
101CS1P
Reducer
2"-LPC-011076301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480202
2"
LPC
011
076301
101CS1P
SA-JER-DS011-TRJR-480219
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480232
2"
LPC
011
078301
101CS1P
2"-LPS-011078302-101CS1P-H
SA-JER-DS011-TRJR-480202
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480232
3/4"
LPC
011
078301
101CS1P
3/4"-LPS-011078302-101CS1P-H
Reducer
-
-
H
25
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480232
2"
LPC
011
078301
101CS1P
Reducer
2"-LPC-011078301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480202
2"
LPC
011
078301
101CS1P
SA-JER-DS011-TRJR-480232
6"-LPC-011071301-101CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
927.1
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
3"
LPS
011
006301
101CS1P
20"-LPS-011071301-101CS1P-H
SA-JER-DS011-TRJR-480011
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480011
3"
LPS
011
006301
101CS1P
SA-JER-DS011-TRJR-480204
3"-BRN-011006301-103CS4P-H
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 6. ALTERNATIVE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480204
3"
LPS
011
006304
101CS1P
20"-LPS-011071301-101CS1P-H
SA-JER-DS011-TRJR-480011
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480011
3"
LPS
011
006304
101CS1P
SA-JER-DS011-TRJR-480204
3"-BRN-011006302-103CS4P-H
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
ALTERNATIVE DESIGN CONDITIONS FV@ 290°C
SA-JER-DS011-TRJR-480204
3"
LPS
011
007301
101CS1P
3"-LPS-011006304-101CS1P-H
SA-JER-DS011-TRJR-480012
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480012
3"
LPS
011
007301
101CS1P
SA-JER-DS011-TRJR-480204
3"-BRN-011007301-103CS4P-H
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 6. ALTERNATIVE DESIGN CONDITIONS: FV @ 290 ºC
-
3"-LPS-011006301-101CS1P-H
SA-JER-DS011-TRJR-480012
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480012
3"
LPS
011
007303
101CS1P
SA-JER-DS011-TRJR-480204
3"-BRN-011007302-103CS4P-H
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
ALTERNATIVE DESIGN CONDITIONS: FV @ 290 ºC
SA-JER-DS011-TRJR-480042
18"
LPS
011
017001
101CS1P
18"-LPS-011017011-101CJ1P-H
SA-JER-DS011-TRJR-480044
-
-
H
100
LP STEAM
Gas
-
1.60
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480042
10"
LPS
011
017001
101CS1P
10"-LPS-011017011-101CJ1P-H
Reducer
-
-
H
100
LP STEAM
Gas
-
1.60
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480042
18"
LPS
011
017001
101CS1P
Reducer
18"-LPS-011017001-101CS1P-H
-
-
H
100
LP STEAM
Gas
-
1.60
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480042
2"
LPS
011
017001
101CS1P
18"-LPS-011017001-101CS1P-H
011-TI-0358
-
-
H
75
LP STEAM
Gas
-
1.60
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480042
2"
LPS
011
017001
101CS1P
18"-LPS-011017001-101CS1P-H
011-TT-0359
-
-
H
75
LP STEAM
Gas
-
1.60
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480042
12"
LPS
011
017001
101CS1P
18"-LPS-011017001-101CS1P-H
3/4"-LPS-011017001-101CS1P-H
-
-
H
100
LP STEAM
Gas
-
1.60
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480042
3/4"
LPS
011
017001
101CS1P
12"-LPS-011017001-101CS1P-H
Plug
-
-
H
65
LP STEAM
Gas
-
1.60
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480044
18"
LPS
011
017001
101CS1P
SA-JER-DS011-TRJR-480042
18"-LPS-011018001-101CL4P-H
-
-
H
100
LP STEAM
Gas
-
1.60
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480044
3/4"
LPS
011
017001
101CS1P
18"-LPS-011017001-101CS1P-H
Blind flange
-
-
H
65
LP STEAM
Gas
-
1.60
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480042
6"
LPS
011
017002
101CJ1P
011-PZV-0009
Reducer
-
-
P
25
AIR
Gas
-
0.00
27.00
-
-
0.00
-
H
0.00
NFS
YES
M
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10.
SA-JER-DS011-TRJR-480204
3"
SA-JER-DS011-TRJR-380001
LPS
011
007303
101CS1P
NOTE 7
478.00
Page 110 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7) MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10.
SA-JER-DS011-TRJR-480042
8"
LPS
011
017002
101CJ1P
Reducer
ATM
-
-
P
25
AIR
Gas
-
0.00
27.00
-
-
0.00
478.00
-
Visual Test
0.00
NFS
YES
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
2"
LPS
011
017002
101CJ1P
2"-LPS-011017010-103CJ1P-H
8"-LPS-011017002-101CJ1P-P
-
-
P
25
AIR
Gas
-
0.00
27.00
-
-
0.00
478.00
-
H
0.00
NFS
YES
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
6"
LPS
011
017003
101CJ1P
011-PZV-0010
Reducer
-
-
P
25
AIR
Gas
-
0.00
27.00
-
-
0.00
478.00
-
H
0.00
NFS
YES
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
8"
LPS
011
017003
101CJ1P
Reducer
ATM
-
-
P
25
AIR
Gas
-
0.00
27.00
-
-
0.00
478.00
-
Visual Test
0.00
NFS
YES
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
2"
LPS
011
017003
101CJ1P
2"-LPS-011017010-103CJ1P-H
8"-LPS-011017003-101CJ1P-P
-
-
P
25
AIR
Gas
-
0.00
27.00
-
-
0.00
478.00
-
H
0.00
NFS
YES
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
8"
LPS
011
017005
101CJ1P
16"-LPS-011017011-101CJ1P-H
Reducer
-
-
H
100
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
6"
LPS
011
017005
101CJ1P
Reducer
SA-JER-DS011-TRJR-480054
-
-
H
100
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480054
6"
LPS
011
017005
101CJ1P
SA-JER-DS011-TRJR-480042
Reducer
-
-
H
100
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC.
SA-JER-DS011-TRJR-480054
4"
LPS
011
017005
101CJ1P
Reducer
4"-LPS-011023004-101CS2P-H
-
-
H
100
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC.
SA-JER-DS011-TRJR-480054
6"
LPS
011
017005
101CJ1P
6"-LPS-011017005-101CJ1P-H
Reducer
-
-
H
100
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC.
SA-JER-DS011-TRJR-480054
3/4"
LPS
011
017005
101CJ1P
6"-LPS-011017005-101CJ1P-H
Plug
-
-
H
65
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC.
SA-JER-DS011-TRJR-480054
1/2"
LPS
011
017005
101CJ1P
011-FE-0027
011-FT-0027
-
-
H
65
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC.
SA-JER-DS011-TRJR-480054
1/2"
LPS
011
017005
101CJ1P
011-FE-0027
011-FT-0027
-
-
H
65
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC.
SA-JER-DS011-TRJR-480054
4"
LPS
011
017005
101CJ1P
Reducer
Reducer
-
-
H
100
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC.
SA-JER-DS011-TRJR-480054
8"
LPS
011
017005
101CJ1P
Reducer
8"-LPS-011023004-101CS2P-H
-
-
H
100
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC.
SA-JER-DS011-TRJR-480054
3/4"
LPS
011
017005
101CJ1P
8"-LPS-011017005-101CJ1P-H
Plug
-
-
H
65
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC.
SA-JER-DS011-TRJR-480042
8"
LPS
011
017006
101CJ1P
8"-LPS-011017005-101CJ1P-H
SA-JER-DS011-TRJR-480056
-
-
H
100
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480056
8"
LPS
011
017006
101CJ1P
SA-JER-DS011-TRJR-480042
Reducer
-
-
H
100
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480056
1/2"
LPS
011
017006
101CJ1P
011-FE-0028
011-FT-0028
-
-
H
65
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480056
3/4"
LPS
011
017006
101CJ1P
8"-LPS-011017006-101CJ1P-H
Plug
-
-
H
65
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480056
1/2"
LPS
011
017006
101CJ1P
011-FE-0028
011-FT-0028
-
-
H
65
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480056
6"
LPS
011
017006
101CJ1P
8"-LPS-011017006-101CJ1P-H
Reducer
-
-
H
100
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480056
4"
LPS
011
017006
101CJ1P
Reducer
4"-LPS-011024004-101CS1P-H
-
-
H
100
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480056
4"
LPS
011
017006
101CJ1P
Reducer
Reducer
-
-
H
100
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480056
8"
LPS
011
017006
101CJ1P
Reducer
8"-LPS-011024004-101CS1P-H
-
-
H
100
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480056
3/4"
LPS
011
017006
101CJ1P
8"-LPS-011017006-101CJ1P-H
Plug
-
-
H
65
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
4"
LPS
011
017008
101CS1P
18"-LPS-011017001-101CS1P-H
011-Y-0004
-
-
H
100
LP STEAM
Gas
-
1.60
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. -
SA-JER-DS011-TRJR-480042
6"
LPS
011
017010
103CJ1P
16"-LPS-011017015-103CJ1P-H
Reducer
-
-
H
100
LP STEAM
Gas
-
2.70
376.00
-
-
7.00
-1.00
440.00
440.00
-
H
14.23
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC.
SA-JER-DS011-TRJR-480042
3/4"
LPS
011
017010
103CJ1P
6"-LPS-011017010-103CJ1P-H
Blind flange
-
-
H
65
LP STEAM
Gas
-
2.70
376.00
-
-
7.00
-1.00
440.00
440.00
-
H
14.23
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC.
SA-JER-DS011-TRJR-480042
4"
LPS
011
017010
103CJ1P
Reducer
011-PZV-0009
-
-
H
100
LP STEAM
Gas
-
2.70
376.00
-
-
7.00
-1.00
440.00
440.00
-
H
14.23
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC.
SA-JER-DS011-TRJR-480042
6"
LPS
011
017010
103CJ1P
6"-LPS-011017010-103CJ1P-H
Reducer
-
-
H
100
LP STEAM
Gas
-
2.70
376.00
-
-
7.00
-1.00
440.00
440.00
-
H
14.23
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC.
SA-JER-DS011-TRJR-480042
3/4"
LPS
011
017010
103CJ1P
6"-LPS-011017010-103CJ1P-H
Blind flange
-
-
H
65
LP STEAM
Gas
-
2.70
376.00
-
-
7.00
-1.00
440.00
440.00
-
H
14.23
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC.
SA-JER-DS011-TRJR-480042
4"
LPS
011
017010
103CJ1P
Reducer
011-PZV-0010
-
-
H
100
LP STEAM
Gas
-
2.70
376.00
-
-
7.00
-1.00
440.00
440.00
-
H
14.23
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC.
SA-JER-DS011-TRJR-480042
2"
LPS
011
017010
103CJ1P
6"-LPS-011017010-103CJ1P-H
2"-LPS-011017002-101CJ1P-P
-
-
H
75
LP STEAM
Gas
-
2.70
376.00
-
-
7.00
-1.00
440.00
440.00
-
H
14.23
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC.
SA-JER-DS011-TRJR-480042
3/4"
LPS
011
017010
103CJ1P
2"-LPS-011017010-103CJ1P-H
Blind flange
-
-
H
65
LP STEAM
Gas
-
2.70
376.00
-
-
7.00
-1.00
440.00
440.00
-
H
14.23
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC.
SA-JER-DS011-TRJR-480042
2"
LPS
011
017010
103CJ1P
6"-LPS-011017010-103CJ1P-H
2"-LPS-011017003-101CJ1P-P
-
-
H
75
LP STEAM
Gas
-
2.70
376.00
-
-
7.00
-1.00
440.00
440.00
-
H
14.23
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC.
SA-JER-DS011-TRJR-480042
3/4"
LPS
011
017010
103CJ1P
2"-LPS-011017010-103CJ1P-H
Blind flange
-
-
H
65
LP STEAM
Gas
-
2.70
376.00
-
-
7.00
-1.00
440.00
440.00
-
H
14.23
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC.
SA-JER-DS011-TRJR-480042
16"
LPS
011
017011
101CJ1P
011-DS-0001
Reducer
-
-
H
100
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
10"
LPS
011
017011
101CJ1P
Reducer
10"-LPS-011017001-101CS1P-H
-
-
H
100
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
16"
LPS
011
017011
101CJ1P
16"-LPS-011017011-101CJ1P-H
Reducer
-
-
H
100
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
1/2"
LPS
011
017011
101CJ1P
011-FE-0021
011-FT-0021
-
-
H
65
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
2"
LPS
011
017011
101CJ1P
16"-LPS-011017011-101CJ1P-H
011-TT-0360
-
-
H
75
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
3/4"
LPS
011
017011
101CJ1P
16"-LPS-011017011-101CJ1P-H
Plug
-
-
H
65
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
2"
LPS
011
017011
101CJ1P
16"-LPS-011017011-101CJ1P-H
011-TT-0043
-
-
H
75
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
1/2"
LPS
011
017011
101CJ1P
011-FE-0021
011-FT-0021
-
-
H
65
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
12"
LPS
011
017011
101CJ1P
Reducer
Reducer
-
-
H
100
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
18"
LPS
011
017011
101CJ1P
Reducer
18"-LPS-011017001-101CS1P-H
-
-
H
100
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
3/4"
LPS
011
017011
101CJ1P
18"-LPS-011017011-101CJ1P-H
Plug
-
-
H
65
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
6"
LPS
011
017012
101CJ1P
16"-LPS-011017011-101CJ1P-H
011-RO-0026
-
-
H
100
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
3/4"
LPS
011
017012
101CJ1P
6"-LPS-011017012-101CJ1P-H
Plug
-
-
H
65
LP STEAM
Gas
-
2.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
13.44
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
6"
LPS
011
017014
101CS1P
011-RO-0026
Reducer
-
-
P
75
LP STEAM
Gas
-
1.70
350.00
-
-
3.50
386.00
-
H
7.18
NFS
By Code
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
10"
LPS
011
017014
101CS1P
Reducer
011-Y-0003
-
-
P
100
LP STEAM
Gas
-
1.70
350.00
-
-
3.50
386.00
-
H
7.18
NFS
By Code
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
16"
LPS
011
017015
103CJ1P
011-F-0001
011-DS-0001
-
-
H
100
LP STEAM
Gas
-
2.70
376.00
-
-
7.00
-1.00
440.00
440.00
-
H
14.23
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. MAX. TEMPERATURE FOR THERMAL EXPANSION: 450ºC. NOTE 10. -
SA-JER-DS011-TRJR-480042
2"
LPS
011
017015
103CJ1P
16"-LPS-011017015-103CJ1P-H
011-TT-0091
-
-
H
75
LP STEAM
Gas
-
2.70
376.00
-
-
7.00
-1.00
440.00
440.00
-
H
14.23
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
12"
LPS
011
017301
101CS1P
16"-LPS-011071301-101CS1P-H
SA-JER-DS011-TRJR-480042
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
12"
LPS
011
017301
101CS1P
SA-JER-DS011-TRJR-480204
011-F-0001
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480044
18"
LPS
011
018001
101CL4P
18"-LPS-011017001-101CS1P-H
Reducer
-
-
H
100
LP STEAM
Gas
-
1.60
350.00
-
-
3.50
-1.00
390.00
370.00
-
H
7.40
NFS
YES
N or Q
N
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@370ºC.
SA-JER-DS011-TRJR-480044
18"
LPS
011
018001
101CL4P
18"-LPS-011018001-101CL4P-H
Reducer
-
-
H
100
LP STEAM
Gas
-
1.60
350.00
-
-
3.50
-1.00
390.00
370.00
-
H
7.40
NFS
YES
N or Q
N
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@370ºC.
SA-JER-DS011-TRJR-480044
12"
LPS
011
018001
101CL4P
Reducer
011-C-0002
-
-
H
100
LP STEAM
Gas
-
1.60
350.00
-
-
3.50
-1.00
390.00
370.00
-
H
7.40
NFS
YES
N or Q
N
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@370ºC.
SA-JER-DS011-TRJR-480044
12"
LPS
011
018001
101CL4P
Reducer
011-C-0002
-
-
H
100
LP STEAM
Gas
-
1.60
350.00
-
-
3.50
-1.00
390.00
370.00
-
H
7.40
NFS
YES
N or Q
N
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV@370ºC.
SA-JER-DS011-TRJR-480204
4"
LPS
011
022301
101CS1P
16"-LPS-011071301-101CS1P-H
SA-JER-DS011-TRJR-480052
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
4"
LPS
011
022301
101CS1P
SA-JER-DS011-TRJR-480204
011-C-0004
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
2"
LPS
011
022301
101CS1P
UC
4"-LPS-011022301-101CS1P-H
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
3/4"
LPS
011
022301
101CS1P
4"-LPS-011022301-101CS1P-H
Plug
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
4"
LPS
011
022301
101CS1P
4"-LPS-011022301-101CS1P-H
011-C-0004
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480054
4"
LPS
011
023002
101CS2P
8"-LPS-011023004-101CS2P-H
011-Y-0005
-
-
H
100
LP STEAM
Gas
-
1.30
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 386ºC.
SA-JER-DS011-TRJR-480054
8"
LPS
011
023004
101CS2P
8"-LPS-011017005-101CJ1P-H
8"-LPS-011023004-101CS2P-H
-
-
H
100
LP STEAM
Gas
-
1.30
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480054
3/4"
LPS
011
023004
101CS2P
8"-LPS-011023004-101CS2P-H
Plug
-
-
H
65
LP STEAM
Gas
-
1.30
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480054
8"
LPS
011
023004
101CS2P
8"-LPS-011023004-101CS2P-H
011-TI-0364
-
-
H
100
LP STEAM
Gas
-
1.30
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480054
8"
LPS
011
023004
101CS2P
8"-LPS-011023004-101CS2P-H
011-TT-0363
-
-
H
100
LP STEAM
Gas
-
1.30
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480054
6"
LPS
011
023004
101CS2P
Reducer
8"-LPS-011023004-101CS2P-H
-
-
H
100
LP STEAM
Gas
-
1.30
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480054
4"
LPS
011
023004
101CS2P
4"-LPS-011017005-101CJ1P-H
Reducer
-
-
H
100
LP STEAM
Gas
-
1.30
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480054
8"
LPS
011
023004
101CS2P
8"-LPS-011023004-101CS2P-H
Cap
-
-
H
100
LP STEAM
Gas
-
1.30
350.00
-
-
3.90
370.00
-
H
7.08
NFS
By Code
N or Q
N
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@370º C
SA-JER-DS011-TRJR-480054
8"
LPS
011
023004
101CS2P
8"-LPS-011023004-101CS2P-H
Cap
-
-
H
100
LP STEAM
Gas
-
1.30
350.00
-
-
3.90
370.00
-
H
7.08
NFS
By Code
N or Q
N
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@370º C
SA-JER-DS011-TRJR-480054
6"
LPS
011
023004
101CS2P
8"-LPS-011023004-101CS2P-H
011-C-0005
-
-
H
100
LP STEAM
Gas
-
1.30
350.00
-
-
3.90
370.00
-
H
7.08
NFS
By Code
N or Q
N
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@370º C.
SA-JER-DS011-TRJR-480054
6"
LPS
011
023004
101CS2P
8"-LPS-011023004-101CS2P-H
011-C-0005
-
-
H
100
LP STEAM
Gas
-
1.30
350.00
-
-
3.90
-
H
7.08
NFS
By Code
N or Q
N
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@370º C.
SA-JER-DS011-TRJR-480054
4"
LPS
011
023004
101CS2P
8"-LPS-011023004-101CS2P-H
3/4"-LPS-011023004-101CS2P-H
-
-
H
100
LP STEAM
Gas
-
1.30
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480054
3/4"
LPS
011
023004
101CS2P
4"-LPS-011023004-101CS2P-H
Plug
-
-
H
65
LP STEAM
Gas
-
1.30
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480056
4"
LPS
011
024002
101CS1P
8"-LPS-011024004-101CS1P-H
011-Y-0006
-
-
H
100
LP STEAM
Gas
-
1.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
8"
LPS
011
024004
101CS1P
8"-LPS-011017006-101CJ1P-H
8"-LPS-011024004-101CS1P-H
-
-
H
100
LP STEAM
Gas
-
1.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
4"
LPS
011
024004
101CS1P
4"-LPS-011017006-101CJ1P-H
Reducer
-
-
H
100
LP STEAM
Gas
-
1.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
2"
LPS
011
024004
101CS1P
8"-LPS-011024004-101CS1P-H
011-TT-0366
-
-
H
75
LP STEAM
Gas
-
1.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
2"
LPS
011
024004
101CS1P
8"-LPS-011024004-101CS1P-H
011-TI-0367
-
-
H
75
LP STEAM
Gas
-
1.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
370.00
-
Page 111 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
TO
TYPE
INSULATION (NOTE 2)
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480056
6"
LPS
011
024004
101CS1P
Reducer
8"-LPS-011024004-101CS1P-H
-
-
H
100
LP STEAM
Gas
-
1.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480056
3/4"
LPS
011
024004
101CS1P
8"-LPS-011024004-101CS1P-H
Plug
-
-
H
65
LP STEAM
Gas
-
1.40
350.00
-
-
7.00
-1.00
370.00
370.00
-
H
12.71
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480056
8"
LPS
011
024004
101CS1P
8"-LPS-011024004-101CS1P-H
END CAP
-
-
H
100
LP STEAM
Gas
-
1.40
350.00
-
-
3.90
370.00
-
H
7.08
NFS
By Code
N or Q
N
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@370ºC.
SA-JER-DS011-TRJR-480056
8"
LPS
011
024004
101CS1P
8"-LPS-011024004-101CS1P-H
END CAP
-
-
H
100
LP STEAM
Gas
-
1.40
350.00
-
-
3.90
370.00
-
H
7.08
NFS
By Code
N or Q
N
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@370ºC.
SA-JER-DS011-TRJR-480056
6"
LPS
011
024004
101CS1P
8"-LPS-011024004-101CS1P-H
011-C-0006
-
-
H
100
LP STEAM
Gas
-
1.40
350.00
-
-
3.90
370.00
-
H
7.08
NFS
By Code
N or Q
N
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@370ºC.
SA-JER-DS011-TRJR-480056
6"
LPS
011
024004
101CS1P
8"-LPS-011024004-101CS1P-H
011-C-0006
-
-
H
100
LP STEAM
Gas
-
1.40
350.00
-
-
3.90
370.00
-
H
7.08
NFS
By Code
N or Q
N
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@370ºC.
SA-JER-DS011-TRJR-480079
6"
LPS
011
029002
101CJ1P
011-PZV-0017
Reducer
-
-
P
75
AIR
Gas
-
0.00
350.00
-
-
0.00
386.00
-
H
0.00
NFS
YES
Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480079
8"
LPS
011
029002
101CJ1P
Reducer
ATM
Gas
-
0.00
350.00
-
-
0.00
386.00
-
Visual Test
0.00
NFS
YES
Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480079
2"
LPS
011
029002
101CJ1P
2"-LPS-011029005-103CJ1P-H
8"-LPS-011029002-101CJ1P-P
-
-
P
65
AIR
Gas
-
0.00
350.00
-
-
0.00
386.00
-
H
0.00
NFS
YES
Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480079
6"
LPS
011
029003
101CJ1P
011-PZV-0018
Reducer
-
-
P
75
AIR
Gas
-
0.00
350.00
-
-
0.00
386.00
-
H
0.00
NFS
YES
Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480079
8"
LPS
011
029003
101CJ1P
Reducer
ATM
-
-
P
90
AIR
Gas
-
0.00
350.00
-
-
0.00
386.00
-
Visual Test
0.00
NFS
YES
Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480079
2"
LPS
011
029003
101CJ1P
2"-LPS-011029006-103CJ1P-H
8"-LPS-011029003-101CJ1P-P
-
-
P
65
AIR
Gas
-
0.00
350.00
-
-
0.00
386.00
-
H
0.00
NFS
YES
Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480079
16"
LPS
011
029004
101CJ1P
011-DS-0002
SA-JER-DS011-TRJR-480106
-
-
H
100
LP STEAM
Gas
-
1.75
350.00
-
-
7.00
-
H
13.65
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
-
-
P
90
AIR
-1.00
386.00
386.00
NOTE 6
SA-JER-DS011-TRJR-480079
2"
LPS
011
029004
101CJ1P
16"-LPS-011029004-101CJ1P-H
011-TT-0049
-
-
H
75
LP STEAM
Gas
-
1.75
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
13.65
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480106
16"
LPS
011
029004
101CJ1P
SA-JER-DS011-TRJR-480079
16"-LPS-011041006-101CS1P-H
-
-
H
100
LP STEAM
Gas
-
1.75
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
13.65
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480106
16"
LPS
011
029004
101CJ1P
16"-LPS-011029004-101CJ1P-H
Reducer
-
-
H
100
LP STEAM
Gas
-
1.75
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
13.65
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480106
3/4"
LPS
011
029004
101CJ1P
16"-LPS-011029004-101CJ1P-H
Plug
-
-
H
65
LP STEAM
Gas
-
1.75
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
13.65
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480106
3/4"
LPS
011
029004
101CJ1P
16"-LPS-011029004-101CJ1P-H
Plug
-
-
H
65
LP STEAM
Gas
-
1.75
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
13.65
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480106
1/2"
LPS
011
029004
101CJ1P
011-FE-0056
011-FT-0056
-
-
H
65
LP STEAM
Gas
-
1.75
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
13.65
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480106
1/2"
LPS
011
029004
101CJ1P
011-FE-0056
011-FT-0056
-
-
H
65
LP STEAM
Gas
-
1.75
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
13.65
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480106
2"
LPS
011
029004
101CJ1P
16"-LPS-011029004-101CJ1P-H
011-TT-0181
-
-
H
75
LP STEAM
Gas
-
1.75
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
13.65
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480106
10"
LPS
011
029004
101CJ1P
Reducer
10"-LPS-011041006-101CS1P-H
-
-
H
100
LP STEAM
Gas
-
1.75
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
13.65
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480106
12"
LPS
011
029004
101CJ1P
16"-LPS-011029004-101CJ1P-H
HEADER
-
-
H
100
LP STEAM
Gas
-
1.75
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
13.65
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480106
3/4"
LPS
011
029004
101CJ1P
HEADER
Plug
-
-
H
65
LP STEAM
Gas
-
1.75
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
13.65
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480079
6"
LPS
011
029005
103CJ1P
16"-LPS-011029007-103CJ1P-H
Reducer
-
-
H
100
LP STEAM
Gas
-
2.25
382.00
-
-
7.00
-1.00
437.00
437.00
-
H
14.17
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480079
3/4"
LPS
011
029005
103CJ1P
6"-LPS-011029005-103CJ1P-H
Blind flange
-
-
H
65
LP STEAM
Gas
-
2.25
382.00
-
-
7.00
-1.00
437.00
437.00
-
H
14.17
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480079
4"
LPS
011
029005
103CJ1P
Reducer
011-PZV-0017
-
-
H
100
LP STEAM
Gas
-
2.25
382.00
-
-
7.00
-1.00
437.00
437.00
-
H
14.17
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480079
2"
LPS
011
029005
103CJ1P
6"-LPS-011029005-103CJ1P-H
2"-LPS-011029002-101CJ1P-P
-
-
H
75
LP STEAM
Gas
-
2.25
382.00
-
-
7.00
-1.00
437.00
437.00
-
H
14.17
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480079
3/4"
LPS
011
029005
103CJ1P
2"-LPS-011029005-103CJ1P-H
Blind flange
-
-
H
65
LP STEAM
Gas
-
2.25
382.00
-
-
7.00
-1.00
437.00
437.00
-
H
14.17
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480079
6"
LPS
011
029006
103CJ1P
6"-LPS-011029005-103CJ1P-H
Reducer
-
-
H
100
LP STEAM
Gas
-
2.25
382.00
-
-
7.00
-1.00
437.00
437.00
-
H
14.17
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480079
3/4"
LPS
011
029006
103CJ1P
6"-LPS-011029006-103CJ1P-H
Blind flange
-
-
H
65
LP STEAM
Gas
-
2.25
382.00
-
-
7.00
-1.00
437.00
437.00
-
H
14.17
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480079
4"
LPS
011
029006
103CJ1P
Reducer
011-PZV-0018
-
-
H
100
LP STEAM
Gas
-
2.25
382.00
-
-
7.00
-1.00
437.00
437.00
-
H
14.17
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480079
2"
LPS
011
029006
103CJ1P
6"-LPS-011029006-103CJ1P-H
2"-LPS-011029003-101CJ1P-P
-
-
H
75
LP STEAM
Gas
-
2.25
382.00
-
-
7.00
-1.00
437.00
437.00
-
H
14.17
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480079
3/4"
LPS
011
029006
103CJ1P
2"-LPS-011029006-103CJ1P-H
Blind flange
-
-
H
65
LP STEAM
Gas
-
2.25
382.00
-
-
7.00
-1.00
437.00
437.00
-
H
14.17
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480079
16"
LPS
011
029007
103CJ1P
011-F-0002
011-DS-0002
-
-
H
100
LP STEAM
Gas
-
2.25
382.00
-
-
7.00
-1.00
437.00
437.00
-
H
14.17
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480079
2"
LPS
011
029007
103CJ1P
16"-LPS-011029007-103CJ1P-H
Flange
-
-
H
75
LP STEAM
Gas
-
2.25
382.00
-
-
7.00
-1.00
437.00
437.00
-
H
14.17
NFS
YES
N or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480105
10"
LPS
011
040001
101CS1P
10"-LPS-011040004-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
10"
LPS
011
040001
101CS1P
10"-LPS-011040001-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
3/4"
LPS
011
040001
101CS1P
10"-LPS-011040001-101CS1P-H
Plug
-
-
H
25
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
8"
LPS
011
040001
101CS1P
Reducer
8"-LPS-011040001-101CS1P-H
-
-
H
50
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
6"
LPS
011
040001
101CS1P
Reducer
Reducer
-
-
H
50
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480079
12"
LPS
011
040001
101CS1P
SA-JER-DS011-TRJR-480105
011-F-0002
-
-
H
50
LP STEAM
Gas
-
2.50
140.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
10"
LPS
011
040001
101CS1P
Reducer
10"-LPS-011040001-101CS1P-H
-
-
H
50
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
3/4"
LPS
011
040001
101CS1P
10"-LPS-011040001-101CS1P-H
Plug
-
-
H
25
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
10"
LPS
011
040001
101CS1P
10"-LPS-011040001-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
2.50
140.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
8"
LPS
011
040001
101CS1P
8"-LPS-011040001-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
2.50
140.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
3/4"
LPS
011
040001
101CS1P
10"-LPS-011040001-101CS1P-H
011-PT-0332
-
-
H
25
LP STEAM
Gas
-
2.50
140.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
10"
LPS
011
040001
101CS1P
Reducer
10"-LPS-011040001-101CS1P-H
-
-
H
50
LP STEAM
Gas
-
2.50
140.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
3/4"
LPS
011
040001
101CS1P
10"-LPS-011040001-101CS1P-H
10"-LPS-011040001-101CS1P-H
-
-
H
25
LP STEAM
Gas
-
2.50
140.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
12"
LPS
011
040001
101CS1P
Reducer
SA-JER-DS011-TRJR-480079
-
-
H
50
LP STEAM
Gas
-
2.50
140.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
3/4"
LPS
011
040001
101CS1P
12"-LPS-011040001-101CS1P-H
Plug
-
-
H
25
LP STEAM
Gas
-
2.50
140.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
3/4"
LPS
011
040001
101CS1P
12"-LPS-011040001-101CS1P-H
011-PT-0227
-
-
H
25
LP STEAM
Gas
-
2.50
140.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
2"
LPS
011
040001
101CS1P
12"-LPS-011040001-101CS1P-H
011-TT-0176
-
-
H
40
LP STEAM
Gas
-
2.50
140.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480104
12"
LPS
011
040002
101CS1P
011-E-0031-A
12"-LPS-011040002-101CS1P-H
-
-
H
50
LP STEAM
Liquid/Gas Mixture
19
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
12"
LPS
011
040002
101CS1P
SA-JER-DS011-TRJR-480104
011-D-0011
-
-
H
50
LP STEAM
Liquid/Gas Mixture
19
2.60
140.00
-
-
8.50
-1.00
170.00
170.00
-
H
12.75
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480104
12"
LPS
011
040002
101CS1P
12"-LPS-011040002-101CS1P-H
SA-JER-DS011-TRJR-480105
-
-
H
50
LP STEAM
Liquid/Gas Mixture
19
2.60
140.00
-
-
8.50
-1.00
170.00
170.00
-
H
12.75
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480104
12"
LPS
011
040003
101CS1P
011-E-0031-B
12"-LPS-011040003-101CS1P-H
-
-
H
50
LP STEAM
Liquid/Gas Mixture
19
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
12"
LPS
011
040003
101CS1P
SA-JER-DS011-TRJR-480104
011-D-0011
-
-
H
50
LP STEAM
Liquid/Gas Mixture
19
2.60
140.00
-
-
8.50
-1.00
170.00
170.00
-
H
12.75
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480104
12"
LPS
011
040003
101CS1P
12"-LPS-011040003-101CS1P-H
SA-JER-DS011-TRJR-480105
-
-
H
50
LP STEAM
Liquid/Gas Mixture
19
2.60
140.00
-
-
8.50
-1.00
170.00
170.00
-
H
12.75
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
10"
LPS
011
040004
101CS1P
011-D-0011
Reducer
-
-
H
50
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
1/2"
LPS
011
040004
101CS1P
011-FE-0054
011-FT-0054-A
-
-
H
25
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
8"
LPS
011
040004
101CS1P
10"-LPS-011040004-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
1/2"
LPS
011
040004
101CS1P
011-FE-0054
011-FT-0054-B
-
-
H
25
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
1/2"
LPS
011
040004
101CS1P
011-FE-0054
011-FT-0054-A
-
-
H
25
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
1/2"
LPS
011
040004
101CS1P
011-FE-0054
011-FT-0054-B
-
-
H
25
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
6"
LPS
011
040004
101CS1P
Reducer
6"-LPS-011040004-101CS1P-H
-
-
H
50
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
3/4"
LPS
011
040004
101CS1P
10"-LPS-011040004-101CS1P-H
Plug
-
-
H
25
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
6"
LPS
011
040004
101CS1P
Reducer
Reducer
-
-
H
50
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
10"
LPS
011
040004
101CS1P
10"-LPS-011040004-101CS1P-H
HEADER
-
-
H
50
LP STEAM
Gas
-
0.60
140.00
-
-
3.50
-1.00
170.00
386.00
-
H
5.25
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480105
3/4"
LPS
011
040004
101CS1P
HEADER
Plug
-
-
H
25
LP STEAM
Gas
-
0.60
140.00
-
-
3.50
-1.00
170.00
386.00
-
H
5.25
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 460ºC.
SA-JER-DS011-TRJR-480105
10"
LPS
011
040004
101CS1P
Reducer
10"-LPS-011040004-101CS1P-H
-
-
H
50
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
3/4"
LPS
011
040004
101CS1P
10"-LPS-011040004-101CS1P-H
Plug
-
-
H
25
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
10"
LPS
011
040004
101CS1P
10"-LPS-011040004-101CS1P-H
011-Y-0008
-
-
H
50
LP STEAM
Gas
-
0.60
140.00
-
-
3.50
170.00
-
H
5.25
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
6"
LPS
011
040004
101CS1P
6"-LPS-011040004-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
0.60
140.00
-
-
3.50
170.00
-
H
5.25
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
8"
LPS
011
040004
101CS1P
Reducer
10"-LPS-011040004-101CS1P-H
-
-
H
50
LP STEAM
Gas
-
0.60
140.00
-
-
3.50
170.00
-
H
5.25
D
By Code
M or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480105
6"
LPS
011
040006
101CS1P
011-D-0011
Reducer
-
-
P
25
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480105
3/4"
LPS
011
040006
101CS1P
6"-LPS-011040006-101CS1P-P
Plug
-
-
P
25
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480105
3"
LPS
011
040006
101CS1P
Reducer
011-PZV-0029
-
-
P
25
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480105
6"
LPS
011
040006
101CS1P
6"-LPS-011040006-101CS1P-P
Reducer
-
-
P
25
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480105
3/4"
LPS
011
040006
101CS1P
6"-LPS-011040006-101CS1P-P
Plug
-
-
P
25
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480105
3"
LPS
011
040006
101CS1P
Reducer
011-PZV-0028
-
-
P
25
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480105
4"
LPS
011
040007
101CS1P
011-PZV-0028
Reducer
-
-
P
25
AIR
Gas
-
0.00
140.00
-
-
0.00
170.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480105
8"
LPS
011
040007
101CS1P
Reducer
ATM
-
-
P
25
AIR
Gas
-
0.00
140.00
-
-
0.00
170.00
-
Visual Test
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-380001
MAX.TEMPERATURE FOR CLOSED OUTLET: 174ºC. MAX.TEMPERATURE DURING FIRE SCENARIO 178ºC. NOTE 10 MAX.TEMPERATURE FOR CLOSED OUTLET: 174ºC. MAX.TEMPERATURE DURING FIRE SCENARIO 178ºC. NOTE 10 MAX.TEMPERATURE FOR CLOSED OUTLET: 174ºC. MAX.TEMPERATURE DURING FIRE SCENARIO 178ºC. NOTE 10 MAX.TEMPERATURE FOR CLOSED OUTLET: 174ºC. MAX.TEMPERATURE DURING FIRE SCENARIO 178ºC. NOTE 10 MAX.TEMPERATURE FOR CLOSED OUTLET: 174ºC. MAX.TEMPERATURE DURING FIRE SCENARIO 178ºC. NOTE 10 MAX.TEMPERATURE FOR CLOSED OUTLET: 174ºC. MAX.TEMPERATURE DURING FIRE SCENARIO 178ºC. NOTE 10 MAX.TEMPERATURE FOR CLOSED OUTLET: 174ºC. MAX.TEMPERATURE DURING FIRESCENARIOS 178ºC. NOTE 10 MAX.TEMPERATURE FOR CLOSED OUTLET: 174ºC. MAX.TEMPERATURE DURING FIRE SCENARIO 178ºC. NOTE 10
Page 112 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
011-PZV-0029
Reducer
-
-
P
25
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
AIR
Gas
-
0.00
140.00
-
-
0.00
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
170.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
-
(NOTE 7) MAX.TEMPERATURE FOR CLOSED OUTLET: 174ºC. MAX.TEMPERATURE DURING FIRESCENARIOS 178ºC. NOTE 10 MAX.TEMPERATURE FOR CLOSED OUTLET: 174ºC. MAX.TEMPERATURE DURING FIRE SCENARIO 178ºC. NOTE 10 -
SA-JER-DS011-TRJR-480105
4"
LPS
011
040008
101CS1P
SA-JER-DS011-TRJR-480105
8"
LPS
011
040008
101CS1P
Reducer
ATM
-
-
P
25
AIR
Gas
-
0.00
140.00
-
-
0.00
170.00
-
Visual Test
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
SA-JER-DS011-TRJR-480105
3"
LPS
011
040009
101CS1P
011-D-0013
ATM
-
-
P
25
AIR
Gas
-
0.00
107.00
-
-
0.00
135.00
-
Visual Test
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480105
3/4"
LPS
011
040015
101CS1P
10"-LPS-011040004-101CS1P-H
011-SC-0024
-
-
H
25
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
3/4"
LPS
011
040015
101CS1P
10"-LPS-011040004-101CS1P-H
SAMPLE COOLER
-
-
H
25
LP STEAM
Gas
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
M or Q
N
N
N
N
N
N
-
THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE.
SA-JER-DS011-TRJR-480105
12"
LPS
011
040016
101CS4P
12"-LPS-011040301-101CS1P-H
12"-LPS-011040017-101CS1P-H
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
1"
LPS
011
040016
101CS4P
12"-LPS-011040016-101CS4P-H
Blind flange
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
1"
LPS
011
040016
101CS4P
12"-LPS-011040016-101CS4P-H
Blind flange
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
12"
LPS
011
040017
101CS1P
12"-LPS-011040017-101CS1P-H
12"-LPS-011040001-101CS1P-H
-
-
H
50
LP STEAM
Gas
-
2.50
140.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
8"
LPS
011
040017
101CS1P
8"-LPS-011040301-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
2.50
140.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
12"
LPS
011
040017
101CS1P
Reducer
12"-LPS-011040017-101CS1P-H
-
-
H
50
LP STEAM
Gas
-
2.50
140.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
12"
LPS
011
040017
101CS1P
12"-LPS-011040016-101CS4P-H
12"-LPS-011040017-101CS1P-H
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480206
12"
LPS
011
040301
101CS1P
12"-LPS-011071301-101CS1P-H
SA-JER-DS011-TRJR-480105
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
12"
LPS
011
040301
101CS1P
SA-JER-DS011-TRJR-480206
12"-LPS-011040016-101CS4P-H
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
N or Q
N
N
N
N
N
N
-
-
N or Q
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
-
SA-JER-DS011-TRJR-480105
8"
LPS
011
040301
101CS1P
Reducer
8"-LPS-011040017-101CS1P-H
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480105
12"
LPS
011
040301
101CS1P
12"-LPS-011040301-101CS1P-H
Reducer
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
if insulated M or Q SA-JER-DS011-TRJR-480105
-
LPS
011
040601
101CS1P
011-D-0011
TRIM
-
-
H
-
-
-
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
Visual Test
0.00
D
By Code
SA-JER-DS011-TRJR-480105
2"
LPS
011
040601
101CS1P
011-D-0011
011-LT-0063
-
-
H
40
-
-
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
SA-JER-DS011-TRJR-480105
2"
LPS
011
040601
101CS1P
011-D-0011
011-PT-0382
-
-
H
40
-
-
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
SA-JER-DS011-TRJR-480105
2"
LPS
011
040601
101CS1P
011-D-0011
011-LG-0064
-
-
H
40
-
-
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
SA-JER-DS011-TRJR-480105
2"
LPS
011
040601
101CS1P
011-D-0011
011-PT-0094
-
-
H
40
-
-
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
SA-JER-DS011-TRJR-480105
2"
LPS
011
040601
101CS1P
011-D-0011
011-LT-0065
-
-
H
40
-
-
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
SA-JER-DS011-TRJR-480105
2"
LPS
011
040601
101CS1P
011-D-0011
011-LT-0063
-
-
H
40
-
-
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
SA-JER-DS011-TRJR-480105
2"
LPS
011
040601
101CS1P
011-D-0011
011-LG-0064
-
-
H
40
-
-
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
SA-JER-DS011-TRJR-480105
2"
LPS
011
040601
101CS1P
011-D-0011
011-LT-0065
-
-
H
40
-
-
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
SA-JER-DS011-TRJR-480105
2"
LPS
011
040601
101CS1P
011-D-0011
011-PI-0095
-
-
H
40
-
-
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
SA-JER-DS011-TRJR-480105
-
LPS
011
040602
103CS1P
011-D-0011
TRIM
-
-
H
-
-
-
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
Visual Test
0.00
D
By Code
SA-JER-DS011-TRJR-480105
2"
LPS
011
040602
103CS1P
011-D-0011
Blind flange
-
-
H
40
-
-
-
2.60
140.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
SA-JER-DS011-TRJR-480106
6"
LPS
011
041001
101CS1P
011-ZV-0019
Reducer
-
-
P
75
LP STEAM
Gas
-
0.30
350.00
-
-
3.50
-1.00
386.00
386.00
-
H
7.18
NFS
By Code
Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480106
8"
LPS
011
041001
101CS1P
Reducer
011-Y-0009
-
-
P
90
LP STEAM
Gas
-
0.30
350.00
-
-
3.50
-1.00
386.00
386.00
-
H
7.18
NFS
By Code
Q
N
N
N
N
N
N
-
-
32"-LPS-011041006-101CS1P-H
011-Y-0010
-
-
H
100
LP STEAM
Gas
-
-0.20
350.00
-
-
7.00
-1.00
386.00
370.00
-
H
14.36
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
H
100
-
-0.20
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
14.36
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
SA-JER-DS011-TRJR-480106
4"
LPS
011
041004
101CS1P
SA-JER-DS011-TRJR-480106
16"
LPS
011
041006
101CS1P
Reducer
-
LP STEAM
Gas
SA-JER-DS011-TRJR-480106
10"
LPS
011
041006
101CS1P
10"-LPS-011029004-101CJ1P-H
Reducer
-
-
H
100
LP STEAM
Gas
-
-0.20
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
14.36
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480106
2"
LPS
011
041006
101CS1P
32"-LPS-011041006-101CS1P-H
011-TI-0206
-
-
H
75
LP STEAM
Gas
-
-0.20
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
14.36
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480106
2"
LPS
011
041006
101CS1P
32"-LPS-011041006-101CS1P-H
011-TT-0180
-
-
H
75
LP STEAM
Gas
-
-0.20
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
14.36
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480106
16"
LPS
011
041006
101CS1P
Reducer
16"-LPS-011041006-101CS1P-H
-
-
H
100
LP STEAM
Gas
-
-0.20
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
14.36
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480106
32"
LPS
011
041006
101CS1P
Reducer
SA-JER-DS011-TRJR-480081
-
-
H
100
LP STEAM
Gas
-
-0.20
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
14.36
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480081
32"
LPS
011
041006
101CS1P
SA-JER-DS011-TRJR-480106
32"-LPS-011041006-101CS1P-H
-
-
H
100
LP STEAM
Gas
-
-0.20
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
14.36
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480081
3/4"
LPS
011
041006
101CS1P
32"-LPS-011041006-101CS1P-H
Plug
-
-
H
65
LP STEAM
Gas
-
-0.20
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
14.36
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480081
32"
LPS
011
041006
101CS1P
Reducer
Reducer
-
-
H
100
LP STEAM
Gas
-
-0.20
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
14.36
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480081
24"
LPS
011
041006
101CS1P
Reducer
Cap
-
-
H
100
LP STEAM
Gas
-
-0.20
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
14.36
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480081
24"
LPS
011
041006
101CS1P
24"-LPS-011041006-101CS1P-H
011-C-0003
-
-
H
100
LP STEAM
Gas
-
-0.20
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
14.36
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480081
24"
LPS
011
041006
101CS1P
Reducer
Cap
-
-
H
100
LP STEAM
Gas
-
-0.20
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
14.36
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480081
24"
LPS
011
041006
101CS1P
24"-LPS-011041006-101CS1P-H
011-C-0003
-
-
H
100
LP STEAM
Gas
-
-0.20
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
14.36
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
16"-LPS-011029004-101CJ1P-H
SA-JER-DS011-TRJR-480106
6"
LPS
011
041008
101CJ1P
16"-LPS-011029004-101CJ1P-H
011-ZV-0019
-
-
H
100
LP STEAM
Gas
-
1.75
350.00
-
-
7.00
-1.00
386.00
386.00
-
H
13.65
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
12"
LPS
011
047301
101CS1P
16"-LPS-011071301-101CS1P-H
SA-JER-DS011-TRJR-480117
-
-
H
50
LP STEAM
Gas
-
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480117
12"
LPS
011
047301
101CS1P
SA-JER-DS011-TRJR-480204
011-ZV-0107
-
-
H
50
LP STEAM
Gas
-
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
3/4"
LPS
011
047301
101CS1P
12"-LPS-011047301-101CS1P-H
011-PI-0147
-
-
H
25
LP STEAM
Gas
-
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
10"
LPS
011
047301
101CS1P
12"-LPS-011047301-101CS1P-H
3/4"-LPS-011047301-101CS1P-H
-
-
H
50
LP STEAM
Gas
-
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
3/4"
LPS
011
047301
101CS1P
10"-LPS-011047301-101CS1P-H
Plug
-
-
H
25
LP STEAM
Gas
-
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
12"
LPS
011
047302
101CS1P
011-ZV-0107
HEADER
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
2"
LPS
011
047303
101CS1P
12"-LPS-011047302-101CS1P-N
011-F-0001
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
2"
LPS
011
047303
101CS1P
12"-LPS-011047302-101CS1P-N
011-F-0001
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
2"
LPS
011
047303
101CS1P
12"-LPS-011047302-101CS1P-N
011-F-0001
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
2"
LPS
011
047303
101CS1P
12"-LPS-011047302-101CS1P-N
011-F-0001
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
-
Page 113 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480117
2"
LPS
011
047303
101CS1P
12"-LPS-011047302-101CS1P-N
011-F-0001
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
2"
LPS
011
047303
101CS1P
12"-LPS-011047302-101CS1P-N
011-F-0001
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
2"
LPS
011
047303
101CS1P
12"-LPS-011047302-101CS1P-N
011-F-0001
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
2"
LPS
011
047303
101CS1P
12"-LPS-011047302-101CS1P-N
011-F-0001
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
2"
LPS
011
047303
101CS1P
12"-LPS-011047302-101CS1P-N
011-F-0001
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
2"
LPS
011
047304
101CS1P
12"-LPS-011047302-101CS1P-N
011-F-0001
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
2"
LPS
011
047304
101CS1P
12"-LPS-011047302-101CS1P-N
011-F-0001
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
2"
LPS
011
047304
101CS1P
12"-LPS-011047302-101CS1P-N
011-F-0001
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
2"
LPS
011
047304
101CS1P
12"-LPS-011047302-101CS1P-N
011-F-0001
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
2"
LPS
011
047304
101CS1P
12"-LPS-011047302-101CS1P-N
011-F-0001
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
2"
LPS
011
047304
101CS1P
12"-LPS-011047302-101CS1P-N
011-F-0001
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
2"
LPS
011
047304
101CS1P
12"-LPS-011047302-101CS1P-N
011-F-0001
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
2"
LPS
011
047304
101CS1P
12"-LPS-011047302-101CS1P-N
011-F-0001
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
2"
LPS
011
047304
101CS1P
12"-LPS-011047302-101CS1P-N
011-F-0001
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047305
101CS1P
12"-LPS-011047302-101CS1P-N
HEADER
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
End
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
End
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
End
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
End
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
HEADER
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
End
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
End
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
End
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
End
-
-
N
-
LP STEAM
Gas
-
2.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047305
101CS1P
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047305
101CS1P
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047305
101CS1P
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047305
101CS1P
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047306
101CS1P
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047306
101CS1P
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047306
101CS1P
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047306
101CS1P
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047306
101CS1P
1-1/2"-LPS-011047305-101CS1PN 1-1/2"-LPS-011047305-101CS1PN 1-1/2"-LPS-011047305-101CS1PN 1-1/2"-LPS-011047305-101CS1PN 12"-LPS-011047302-101CS1P-N 1-1/2"-LPS-011047306-101CS1PN 1-1/2"-LPS-011047306-101CS1PN 1-1/2"-LPS-011047306-101CS1PN 1-1/2"-LPS-011047306-101CS1PN
if insulated M or Q SA-JER-DS011-TRJR-480117
-
LPS
011
047601
103CS1P
011-F-0001
TRIM
-
-
P
-
-
-
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
Visual Test
0.00
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
011-F-0001
Blind flange
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
011-F-0001
Blind flange
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
011-F-0001
011-PT-0150-B
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
011-F-0001
011-PT-0395
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
1-1/2"-LPS-011047601-103CS1PP
011-DG-0148
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
1-1/2"-LPS-011047601-103CS1PP
011-DG-0148
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
011-F-0001
011-PT-0397-C
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
1-1/2"-LPS-011047601-103CS1PP
011-PT-0145
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
011-F-0001
011-PT-0397-C
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
011-F-0001
Blind flange
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
1-1/2"-LPS-011047601-103CS1PP
011-DG-0148
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
011-F-0001
011-PT-0149
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
011-F-0001
011-PT-0150-B
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
011-F-0001
011-PT-0395
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
1-1/2"-LPS-011047601-103CS1PP
011-DG-0148
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
011-F-0001
011-PT-0145
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-380001
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
Page 114 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7) if insulated M or Q
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
011-F-0001
Blind flange
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
011-F-0001
011-PT-0150-B
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
1-1/2"-LPS-011047601-103CS1PP
011-DG-0148
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
1-1/2"-LPS-011047601-103CS1PP
011-DG-0148
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
1-1/2"-LPS-011047601-103CS1PP
011-DG-0148
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
011-F-0001
Blind flange
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
011-F-0001
Blind flange
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
1-1/2"
LPS
011
047601
103CS1P
011-F-0001
Blind flange
-
-
P
25
-
Gas
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480117
-
LPS
011
047602
101CS1P
011-F-0001
TRIM
-
-
P
-
-
-
-
5.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
Visual Test
0.00
NFS
By Code
SA-JER-DS011-TRJR-480203
12"
LPS
011
050301
101CS1P
16"-LPS-011071301-101CS1P-H
SA-JER-DS011-TRJR-480120
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480120
12"
LPS
011
050301
101CS1P
SA-JER-DS011-TRJR-480203
011-ZV-0108
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
SA-JER-DS011-TRJR-480120
3/4"
LPS
011
050301
101CS1P
12"-LPS-011050301-101CS1P-H
011-PI-0250
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
SA-JER-DS011-TRJR-480120
10"
LPS
011
050301
101CS1P
12"-LPS-011050301-101CS1P-H
3/4"-LPS-011050301-101CS1P-H
H
65
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
SA-JER-DS011-TRJR-480120
3/4"
LPS
011
050301
101CS1P
10"-LPS-011050301-101CS1P-H
Plug
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
SA-JER-DS011-TRJR-480120
12"
LPS
011
050302
101CS1P
011-ZV-0108
HEADER
-
-
N
-
LP STEAM
Gas
-
5.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
SA-JER-DS011-TRJR-480120
2"
LPS
011
050304
101CS1P
12"-LPS-011050302-101CS1P-N
011-F-0002
-
-
N
-
LP STEAM
Gas
-
5.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
SA-JER-DS011-TRJR-480120
2"
LPS
011
050304
101CS1P
2"-LPS-011050304-101CS1P-N
011-F-0002
-
-
N
-
LP STEAM
Gas
-
5.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
SA-JER-DS011-TRJR-480120
2"
LPS
011
050305
101CS1P
12"-LPS-011050302-101CS1P-N
011-F-0002
-
-
N
-
LP STEAM
Gas
-
5.50
25.00
-
-
7.00
-1.00
290.00
290.00
SA-JER-DS011-TRJR-480120
2"
LPS
011
050305
101CS1P
2"-LPS-011050305-101CS1P-N
011-F-0002
-
-
N
-
LP STEAM
Gas
-
5.50
25.00
-
-
7.00
-1.00
290.00
SA-JER-DS011-TRJR-480120
2"
LPS
011
050306
101CS1P
12"-LPS-011050302-101CS1P-N
011-F-0002
-
-
N
-
LP STEAM
Gas
-
5.50
25.00
-
-
7.00
-1.00
SA-JER-DS011-TRJR-480120
2"
LPS
011
050306
101CS1P
2"-LPS-011050306-101CS1P-N
011-F-0002
-
-
N
-
LP STEAM
Gas
-
5.50
25.00
-
-
7.00
-1.00
SA-JER-DS011-TRJR-480120
2"
LPS
011
050307
101CS1P
12"-LPS-011050302-101CS1P-N
011-F-0002
-
-
N
-
LP STEAM
Gas
-
5.50
25.00
-
-
7.00
SA-JER-DS011-TRJR-480120
2"
LPS
011
050307
101CS1P
2"-LPS-011050307-101CS1P-N
011-F-0002
-
-
N
-
LP STEAM
Gas
-
5.50
25.00
-
-
SA-JER-DS011-TRJR-480120
2"
LPS
011
050308
101CS1P
12"-LPS-011050302-101CS1P-N
011-F-0002
-
-
N
-
LP STEAM
Gas
-
5.50
25.00
-
SA-JER-DS011-TRJR-480120
2"
LPS
011
050308
101CS1P
2"-LPS-011050308-101CS1P-N
011-F-0002
-
-
N
-
LP STEAM
Gas
-
5.50
25.00
SA-JER-DS011-TRJR-480120
2"
LPS
011
050309
101CS1P
12"-LPS-011050302-101CS1P-N
011-F-0002
-
-
N
-
LP STEAM
Gas
-
5.50
SA-JER-DS011-TRJR-480120
2"
LPS
011
050309
101CS1P
2"-LPS-011050309-101CS1P-N
011-F-0002
-
-
N
-
LP STEAM
Gas
-
SA-JER-DS011-TRJR-480120
2"
LPS
011
050310
101CS1P
12"-LPS-011050302-101CS1P-N
011-F-0002
-
-
N
-
LP STEAM
Gas
SA-JER-DS011-TRJR-480120
2"
LPS
011
050310
101CS1P
2"-LPS-011050310-101CS1P-N
011-F-0002
-
-
N
-
LP STEAM
Gas
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050311
101CS1P
12"-LPS-011050302-101CS1P-N
HEADER
-
-
N
-
LP STEAM
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050311
101CS1P
011-F-0002
-
-
N
-
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050311
011-F-0002
-
-
N
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050311
011-F-0002
-
-
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050312
1-1/2"-LPS-011050311-101CS1PN 1-1/2"-LPS-011050311-101CS1P101CS1P N 1-1/2"-LPS-011050311-101CS1P101CS1P N 101CS1P 12"-LPS-011050302-101CS1P-N
HEADER
-
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050312
101CS1P
011-F-0002
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050312
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050312
1-1/2"-LPS-011050312-101CS1PN 1-1/2"-LPS-011050312-101CS1P101CS1P N 1-1/2"-LPS-011050312-101CS1P101CS1P N
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N or Q
N
N
N
N
N
N
-
-
N or Q
N
N
N
N
N
N
-
-
By Code
N or Q
N
N
N
N
N
N
-
-
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
NFS
By Code
Q
N
N
N
N
N
N
-
-
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
H
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
-
H
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
290.00
-
H
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
290.00
290.00
-
H
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
290.00
290.00
-
H
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
5.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
-
5.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
-
5.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
Gas
-
5.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
LP STEAM
Gas
-
5.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
-
LP STEAM
Gas
-
5.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
N
-
LP STEAM
Gas
-
5.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
-
N
-
LP STEAM
Gas
-
5.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
-
-
N
-
LP STEAM
Gas
-
5.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
011-F-0002
-
-
N
-
LP STEAM
Gas
-
5.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
011-F-0002
-
-
N
-
LP STEAM
Gas
-
5.50
25.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
Q
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
-
-
LP STEAM
Gas
-
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
if insulated N or Q -
LPS
011
050601
101CS1P
SA-JER-DS011-TRJR-480120
-
LPS
011
050602
103CS1P
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050602
103CS1P
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050602
103CS1P
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050602
103CS1P
SA-JER-DS011-TRJR-480120
TRIM
-
-
End
End
-
-
011-F-0002
011-PT-0248-B
-
-
011-F-0002
011-PT-0248-A
-
-
011-F-0002
011-PT-0246
-
Gate valve
011-F-0002
P
-
-
-
-
-
-
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
-
-
NFS By Code
N or Q
N
N
N
N
N
N
-
-
P
25
-
-
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS By Code
N or Q
N
N
N
N
N
N
-
-
P
25
-
-
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS By Code
N or Q
N
N
N
N
N
N
-
-
-
P
25
-
-
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS By Code
N or Q
N
N
N
N
N
N
-
-
-
-
P
25
-
-
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS By Code
N or Q
N
N
N
N
N
N
-
-
Gate valve
-
-
P
25
-
-
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS By Code
N or Q
N
N
N
N
N
N
-
-
-
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
Visual Test
0.00
NFS
By Code
if NOT insulated B or Q
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050602
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050602
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050602
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050602
1-1/2"-LPS-011050602-103CS1P103CS1P H 1-1/2"-LPS-011050602-103CS1P103CS1P H 1-1/2"-LPS-011050602-103CS1P103CS1P H 103CS1P 011-F-0002
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050602
103CS1P
011-F-0002
011-PT-0411-C
-
-
P
25
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050602
103CS1P
1-1/2"-LPS-011050602-103CS1PH
Gate valve
-
-
P
25
-
-
-
5.50
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050602
103CS1P
Gate valve
1-1/2"-LPS-011050602-103CS1PH
-
-
P
25
-
-
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050602
103CS1P
011-F-0002
011-PT-0408
-
-
P
25
-
-
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050602
103CS1P
1-1/2"-LPS-011050602-103CS1PH
Gate valve
-
-
P
25
-
-
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050602
103CS1P
011-F-0002
011-PT-0248-C
-
-
P
25
-
-
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050602
103CS1P
011-F-0002
011-PT-0407
-
-
P
25
-
-
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480120
1-1/2"
LPS
011
050602
103CS1P
011-F-0002
011-PT-0244
-
-
P
25
-
-
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
By Code NFS
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480204
8"
LPS
011
051301
101CS1P
16"-LPS-011071301-101CS1P-H
SA-JER-DS011-TRJR-480121
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
011
051301
101CS1P
-
P
25
-
-
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS By Code
N or Q
N
N
N
N
N
N
-
-
011-PT-0411-B
-
-
P
25
-
-
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS By Code
N or Q
N
N
N
N
N
N
-
-
-
-
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS By Code
N or Q
N
N
N
N
N
N
-
-
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480204
011-TV-0223
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
8"
LPS
011
051301
101CS1P
8"-LPS-011051301-101CS1P-H
8"-LPS-011051301-101CS1P-H
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480121
3/4"
LPS
011
051301
101CS1P
8"-LPS-011051301-101CS1P-H
Plug
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480121
8"
LPS
011
051301
101CS1P
011-TV-0223
011-E-0041
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480121
3/4"
LPS
011
051301
101CS1P
8"-LPS-011051301-101CS1P-H
Plug
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
LPS
-
SA-JER-DS011-TRJR-480121
SA-JER-DS011-TRJR-480121
8"
Gate valve
Page 115 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480121
8"
LPS
011
051301
101CS1P
8"-LPS-011051301-101CS1P-H
8"-LPS-011051301-101CS1P-H
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480121
3"
LPS
011
051302
101CS1P
011-E-0041
3"-LPC-011051301-101CS1P-H
-
-
H
40
LP STEAM
Gas
-
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480121
3"
LPS
011
051302
101CS1P
3"-LPS-011051302-101CS1P-H
Reducer
-
-
H
40
LP STEAM
Gas
-
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480121
3/4"
LPS
011
051302
101CS1P
3"-LPS-011051302-101CS1P-H
Plug
-
-
H
25
LP STEAM
Gas
-
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480121
3/4"
LPS
011
051302
101CS1P
3"-LPS-011051302-101CS1P-H
Plug
-
-
H
25
LP STEAM
Gas
-
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480121
3/4"
LPS
011
051302
101CS1P
3"-LPS-011051302-101CS1P-H
Plug
-
-
H
25
LP STEAM
Gas
-
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
-
-
-
H
40
LP STEAM
Gas
-
2.50
139.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
M or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480121
1-1/2"
LPS
011
051302
101CS1P
Reducer
1-1/2"-LPC-011051301-101CS1PH
SA-JER-DS011-TRJR-480201
6"
LPS
011
071001
101CS1P
011-D-0026
Reducer
-
-
P
25
LP STEAM
Gas
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480201
3/4"
LPS
011
071001
101CS1P
6"-LPS-011071001-101CS1P-P
Plug
-
-
P
25
LP STEAM
Gas
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480201
3"
LPS
011
071001
101CS1P
Reducer
011-PZV-0063
-
-
P
25
LP STEAM
Gas
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480201
6"
LPS
011
071001
101CS1P
6"-LPS-011071001-101CS1P-P
Reducer
-
-
P
25
LP STEAM
Gas
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480201
3/4"
LPS
011
071001
101CS1P
6"-LPS-011071001-101CS1P-P
Plug
-
-
P
25
LP STEAM
Gas
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480201
3"
LPS
011
071001
101CS1P
Reducer
011-PZV-0064
-
-
P
25
LP STEAM
Gas
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480201
2"
LPS
011
071001
101CS1P
6"-LPS-011071001-101CS1P-P
2"-LPS-011071005-101CS1P-P
-
-
P
25
LP STEAM
Gas
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 150ºC.
SA-JER-DS011-TRJR-480201
3/4"
LPS
011
071001
101CS1P
2"-LPS-011071001-101CS1P-P
Plug
-
-
P
25
LP STEAM
Gas
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 150ºC.
SA-JER-DS011-TRJR-480201
4"
LPS
011
071002
101CS1P
011-D-0026
Reducer
-
-
P
25
LP STEAM
Gas
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
3/4"
LPS
011
071002
101CS1P
4"-LPS-011071002-101CS1P-P
011-PT-0455
-
-
P
25
LP STEAM
Gas
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
2"
LPS
011
071002
101CS1P
Reducer
ATM
-
-
P
25
LP STEAM
Gas
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
Visual Test
0.00
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
2"
LPS
011
071002
101CS1P
2"-LPS-011071002-101CS1P-P
ATM
-
-
P
25
LP STEAM
Gas
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
Visual Test
0.00
D
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
4"
LPS
011
071003
101CS1P
4"-LPS-011071002-101CS1P-P
011-A-0008
-
-
P
25
LP STEAM
Gas
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480201
4"
LPS
011
071004
101CS1P
011-PZV-0063
Reducer
-
-
P
25
AIR
Gas
-
0.00
134.00
-
-
0.00
150.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480201
8"
LPS
011
071004
101CS1P
Reducer
ATM
-
-
P
25
AIR
Gas
-
0.00
134.00
-
-
0.00
150.00
-
Visual Test
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480201
4"
LPS
011
071005
101CS1P
011-PZV-0064
Reducer
-
-
P
25
AIR
Gas
-
0.00
134.00
-
-
0.00
150.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480201
8"
LPS
011
071005
101CS1P
Reducer
ATM
-
-
P
25
AIR
Gas
-
0.00
134.00
-
-
0.00
150.00
-
Visual Test
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480201
2"
LPS
011
071005
101CS1P
2"-LPS-011071001-101CS1P-P
8"-LPS-011071005-101CS1P-P
-
-
P
25
AIR
Gas
-
0.00
134.00
-
-
0.00
150.00
-
H
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480202
20"
LPS
011
071301
101CS1P
IP-1329 L
SA-JER-DS011-TRJR-480204
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480202
3/4"
LPS
011
071301
101CS1P
20"-LPS-011071301-101CS1P-H
Plug
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480202
3/4"
LPS
011
071301
101CS1P
20"-LPS-011071301-101CS1P-H
011-PT-0267
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480202
1/2"
LPS
011
071301
101CS1P
011-FE-0093
011-FT-0093
-
-
H
25
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480202
2"
LPS
011
071301
101CS1P
20"-LPS-011071301-101CS1P-H
011-TT-0249
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480202
3/4"
LPS
011
071301
101CS1P
20"-LPS-011071301-101CS1P-H
011-PI-0268
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480202
1/2"
LPS
011
071301
101CS1P
011-FE-0093
011-FT-0093
-
-
H
25
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
20"
LPS
011
071301
101CS1P
SA-JER-DS011-TRJR-480202
Reducer
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
12"
LPS
011
071301
101CS1P
Reducer
SA-JER-DS011-TRJR-480206
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
20"
LPS
011
071301
101CS1P
20"-LPS-011071301-101CS1P-H
Reducer
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
16"
LPS
011
071301
101CS1P
Reducer
SA-JER-DS011-TRJR-480313
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480206
12"
LPS
011
071301
101CS1P
SA-JER-DS011-TRJR-480204
HEADER
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480313
16"
LPS
011
071301
101CS1P
SA-JER-DS011-TRJR-480204
SA-JER-DS011-TRJR-480205
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480205
16"
LPS
011
071301
101CS1P
SA-JER-DS011-TRJR-480313
SA-JER-DS011-TRJR-480203
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480203
16"
LPS
011
071301
101CS1P
SA-JER-DS011-TRJR-480205
HEADER
-
-
H
65
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480202
2"
LPS
011
071303
101CS1P
IP-1334 L
SA-JER-DS011-TRJR-480204
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS -
SA-JER-DS011-TRJR-480310
2"
LPS
011
071303
101CS1P
2"-LPS-011071303-101CS1P-H
SA-JER-DS011-TRJR-480315
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
2"
LPS
011
071303
101CS1P
SA-JER-DS011-TRJR-480308
SA-JER-DS011-TRJR-480310
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
3/4"
LPS
011
071303
101CS1P
2"-LPS-011071303-101CS1P-H
011-PI-0439
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
2"
LPS
011
071303
101CS1P
2"-LPS-011071303-101CS1P-H
SA-JER-DS011-TRJR-480314
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
2"
LPS
011
071303
101CS1P
SA-JER-DS011-TRJR-480309
HEADER
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
2"
LPS
011
071303
101CS1P
SA-JER-DS011-TRJR-480306
HEADER
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
2"
LPS
011
071303
101CS1P
LPS
SA-JER-DS011-TRJR-480307
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
2"
LPS
011
071303
101CS1P
SA-JER-DS011-TRJR-480314
SA-JER-DS011-TRJR-480309
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
3/4"
LPS
011
071303
101CS1P
2"-LPS-011071303-101CS1P-H
Plug
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
2"
LPS
011
071303
101CS1P
2"-LPS-011071303-101CS1P-H
SA-JER-DS011-TRJR-480206
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480206
2"
LPS
011
071303
101CS1P
SA-JER-DS011-TRJR-480202
HEADER
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480204
2"
LPS
011
071303
101CS1P
SA-JER-DS011-TRJR-480202
SA-JER-DS011-TRJR-480313
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480313
2"
LPS
011
071303
101CS1P
SA-JER-DS011-TRJR-480204
SA-JER-DS011-TRJR-480205
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480205
2"
LPS
011
071303
101CS1P
SA-JER-DS011-TRJR-480313
SA-JER-DS011-TRJR-480203
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480203
2"
LPS
011
071303
101CS1P
SA-JER-DS011-TRJR-480205
HEADER
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071306
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-002
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480306
2"
LPS
011
071307
101CS1P
2"-LPS-011071303-101CS1P-H
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071307
101CS1P
Reducer
011-US-003
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071308
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-004
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS -
SA-JER-DS011-TRJR-480306
1"
LPS
011
071309
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-006
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
2"
LPS
011
071310
101CS1P
2"-LPS-011071303-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071310
101CS1P
Reducer
011-US-005
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071311
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-008
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
2"
LPS
011
071312
101CS1P
2"-LPS-011071303-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071312
101CS1P
Reducer
011-US-007
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071313
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-010
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
2"
LPS
011
071314
101CS1P
2"-LPS-011071303-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071314
101CS1P
Reducer
011-US-009
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
2"
LPS
011
071315
101CS1P
2"-LPS-011071303-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071315
101CS1P
Reducer
011-US-011
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071316
101CS1P
2"-LPS-011071346-101CS1P-H
011-US-012
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
LPS
011
071317
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-014
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
LPS
011
071318
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-013
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
LPS
011
071319
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-016
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
LPS
011
071320
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-015
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
LPS
011
071321
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-017
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
2"
LPS
011
071322
101CS1P
2"-LPS-011071303-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
LPS
011
071322
101CS1P
Reducer
011-US-018
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
LPS
011
071323
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-020
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
LPS
011
071324
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-019
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071325
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-001
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
LPS
011
071326
101CS1P
2"-LPS-011071322-101CS1P-H
011-US-021
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
LPS
011
071327
101CS1P
011-US-022
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
2"-LPS-011071303-101CS1P-H
290.00
-1.00
290.00
150.00
MAX.TEMPERATURE DURING FIRE SCENARIO: 150ºC. NOTE 10. MAX.TEMPERATURE DURING FIRE SCENARIO: 150ºC. NOTE 10. MAX.TEMPERATURE DURING FIRE SCENARIO: 150ºC. NOTE 10. MAX.TEMPERATURE DURING FIRE SCENARIO: 150ºC. NOTE 10. MAX.TEMPERATURE DURING FIRE SCENARIO: 150ºC. NOTE 10. MAX.TEMPERATURE DURING FIRE SCENARIO: 150ºC. NOTE 10.
MAX.TEMPERATURE DURING FIRE SCENARIO: 150ºC. NOTE 10. MAX.TEMPERATURE DURING FIRE SCENARIO: 150ºC. NOTE 10. MAX.TEMPERATURE DURING FIRE SCENARIO: 150ºC. NOTE 10. MAX.TEMPERATURE DURING FIRE SCENARIO: 150ºC. NOTE 10. MAX.TEMPERATURE DURING FIRE SCENARIO: 150ºC. NORMAL OPERATING TEMPERATURE 160 ºC, CONSIDERED FOR THE INSULATION THICKNESS. NORMAL OPERATING TEMPERATURE 160 ºC, CONSIDERED FOR THE INSULATION THICKNESS. NORMAL OPERATING TEMPERATURE 160 ºC, CONSIDERED FOR THE INSULATION THICKNESS. NORMAL OPERATING TEMPERATURE 160 ºC, CONSIDERED FOR THE INSULATION THICKNESS. NORMAL OPERATING TEMPERATURE 160 ºC, CONSIDERED FOR THE INSULATION THICKNESS. NORMAL OPERATING TEMPERATURE 160 ºC, CONSIDERED FOR THE INSULATION THICKNESS. NORMAL OPERATING TEMPERATURE 160 ºC, CONSIDERED FOR THE INSULATION THICKNESS. NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS -
-
Page 116 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480307
2"
LPS
011
071328
101CS1P
2"-LPS-011071303-101CS1P-H
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS
SA-JER-DS011-TRJR-480307
1"
LPS
011
071328
101CS1P
Reducer
011-US-024
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
LPS
011
071329
101CS1P
2"-LPS-011071328-101CS1P-H
011-US-023
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071330
101CS1P
2"-LPS-011071315-101CS1P-H
011-US-025
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071331
101CS1P
2"-LPS-011071315-101CS1P-H
011-US-026
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
LPS
011
071332
101CS1P
2"-LPS-011071356-101CS1P-H
011-US-041
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
LPS
011
071333
101CS1P
2"-LPS-011071356-101CS1P-H
011-US-042
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
LPS
011
071334
101CS1P
2"-LPS-011071352-101CS1P-H
011-US-043
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS
SA-JER-DS011-TRJR-480306
1"
LPS
011
071335
101CS1P
2"-LPS-011071310-101CS1P-H
011-US-029
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071336
101CS1P
2"-LPS-011071314-101CS1P-H
011-US-027
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071337
101CS1P
2"-LPS-011071312-101CS1P-H
011-US-028
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071338
101CS1P
2"-LPS-011071307-101CS1P-H
011-US-030
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071339
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-032
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS -
SA-JER-DS011-TRJR-480306
1"
LPS
011
071340
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-031
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
2"
LPS
011
071341
101CS1P
2"-LPS-011071303-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071341
101CS1P
Reducer
011-US-033
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071342
101CS1P
2"-LPS-011071341-101CS1P-H
011-US-034
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS
SA-JER-DS011-TRJR-480306
1"
LPS
011
071343
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-035
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
LPS
011
071344
101CS1P
2"-LPS-011071348-101CS1P-H
011-US-040
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071345
101CS1P
2"-LPS-011071303-101CS1P-H
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-1.00
-1.00
-1.00
-1.00
290.00
290.00
290.00
290.00
290.0
290.0
290.0
290.0
-
-
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
011-US-053
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
2"-LPS-011071357-101CS1P-H
011-US-052
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-055
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-054
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
2"-LPS-011071359-101CS1P-H
011-US-056
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
101CS1P
2"-LPS-011071348-101CS1P-H
011-US-057
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-058
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
071364
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-059
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
011
071365
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-067
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
LPS
011
071366
101CS1P
2"-LPS-011071383-101CS1P-H
1"-LPS-011071366-101CS1P-H
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
LPS
011
071366
101CS1P
1"-LPS-011071366-101CS1P-H
011-US-060
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071345
101CS1P
Reducer
011-US-036
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
SA-JER-DS011-TRJR-480306
2"
LPS
011
071346
101CS1P
SA-JER-DS011-TRJR-480306
1"
LPS
011
071346
101CS1P
2"-LPS-011071303-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
Reducer
011-US-037
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
SA-JER-DS011-TRJR-480314
1"
LPS
011
071347
101CS1P
2"-LPS-011071348-101CS1P-H
011-US-038
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
SA-JER-DS011-TRJR-480314
2"
LPS
011
SA-JER-DS011-TRJR-480314
1"
LPS
011
071348
101CS1P
2"-LPS-011071303-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
071348
101CS1P
Reducer
011-US-039
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
SA-JER-DS011-TRJR-480307
1"
LPS
011
071349
101CS1P
2"-LPS-011071352-101CS1P-H
011-US-044
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
SA-JER-DS011-TRJR-480307
1"
LPS
011
071350
101CS1P
2"-LPS-011071352-101CS1P-H
011-US-045
-
-
H
40
LP STEAM
Gas
-
5.50
SA-JER-DS011-TRJR-480307
1"
LPS
011
071351
101CS1P
2"-LPS-011071352-101CS1P-H
011-US-046
-
-
H
40
LP STEAM
Gas
-
SA-JER-DS011-TRJR-480307
2"
LPS
011
071352
101CS1P
2"-LPS-011071356-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
SA-JER-DS011-TRJR-480307
1"
LPS
011
071352
101CS1P
Reducer
011-US-047
-
-
H
40
LP STEAM
SA-JER-DS011-TRJR-480307
1"
LPS
011
071353
101CS1P
2"-LPS-011071356-101CS1P-H
011-US-049
-
-
H
40
SA-JER-DS011-TRJR-480307
1"
LPS
011
071354
101CS1P
2"-LPS-011071356-101CS1P-H
011-US-048
-
-
H
SA-JER-DS011-TRJR-480307
1"
LPS
011
071355
101CS1P
2"-LPS-011071357-101CS1P-H
011-US-051
-
-
H
SA-JER-DS011-TRJR-480307
2"
LPS
011
071356
101CS1P
2"-LPS-011071303-101CS1P-H
Reducer
-
-
SA-JER-DS011-TRJR-480307
1"
LPS
011
071356
101CS1P
Reducer
011-US-050
-
SA-JER-DS011-TRJR-480307
2"
LPS
011
071357
101CS1P
2"-LPS-011071303-101CS1P-H
Reducer
SA-JER-DS011-TRJR-480307
1"
LPS
011
071357
101CS1P
Reducer
SA-JER-DS011-TRJR-480307
1"
LPS
011
071358
101CS1P
SA-JER-DS011-TRJR-480314
2"
LPS
011
071359
SA-JER-DS011-TRJR-480314
1"
LPS
011
071360
SA-JER-DS011-TRJR-480314
1"
LPS
011
071361
101CS1P
SA-JER-DS011-TRJR-480314
1"
LPS
011
071362
SA-JER-DS011-TRJR-480314
1"
LPS
011
071363
SA-JER-DS011-TRJR-480314
1"
LPS
011
SA-JER-DS011-TRJR-480309
1"
LPS
SA-JER-DS011-TRJR-480308
1"
SA-JER-DS011-TRJR-480308
1"
-1.00
290.00
290.0
290.00 -1.00
290.00
290.0
NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS -
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS -
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480308
1"
LPS
011
071367
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-061
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
SA-JER-DS011-TRJR-480308
1"
LPS
011
071368
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-062
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
SA-JER-DS011-TRJR-480309
1"
LPS
011
071369
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-063
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
SA-JER-DS011-TRJR-480308
1"
LPS
011
071370
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-064
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071371
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-065
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
-1.00
290.00
290.0
-
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS -
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
190.00
-
-
7.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS -
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
011-US-083
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
2"-LPS-011071389-101CS1P-H
011-US-084
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
2"-LPS-011071389-101CS1P-H
011-US-085
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
101CS1P
2"-LPS-011071303-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
071392
101CS1P
Reducer
011-US-086
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
011
071393
101CS1P
2"-LPS-011071400-101CS1P-H
011-US-087
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
LPS
011
071394
101CS1P
2"-LPS-011071400-101CS1P-H
011-US-088
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
1"
LPS
011
071395
101CS1P
2"-LPS-011071400-101CS1P-H
011-US-089
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071396
101CS1P
2"-LPS-011071400-101CS1P-H
011-US-090
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071397
101CS1P
2"-LPS-011071400-101CS1P-H
011-US-093
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071398
101CS1P
2"-LPS-011071400-101CS1P-H
011-US-092
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071399
101CS1P
2"-LPS-011071400-101CS1P-H
011-US-094
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
2"
LPS
011
071400
101CS1P
2"-LPS-011071392-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071400
101CS1P
Reducer
011-US-095
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
2"
LPS
011
071401
101CS1P
2"-LPS-011071303-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071372
101CS1P
2"-LPS-011071303-101CS1P-H
Hose connection
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
SA-JER-DS011-TRJR-480310
1"
LPS
011
071373
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-068
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
SA-JER-DS011-TRJR-480308
1"
LPS
011
071374
101CS1P
2"-LPS-011071384-101CS1P-H
011-US-079
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
SA-JER-DS011-TRJR-480310
1"
LPS
011
071375
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-069
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
SA-JER-DS011-TRJR-480310
1"
LPS
011
071376
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-070
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
SA-JER-DS011-TRJR-480308
1"
LPS
011
071377
101CS1P
2"-LPS-011071383-101CS1P-H
011-US-071
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
SA-JER-DS011-TRJR-480308
1"
LPS
011
071378
101CS1P
2"-LPS-011071383-101CS1P-H
011-US-072
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
SA-JER-DS011-TRJR-480308
1"
LPS
011
071379
101CS1P
2"-LPS-011071384-101CS1P-H
011-US-073
-
-
H
40
LP STEAM
Gas
-
5.50
SA-JER-DS011-TRJR-480308
1"
LPS
011
071380
101CS1P
2"-LPS-011071384-101CS1P-H
011-US-074
-
-
H
40
LP STEAM
Gas
-
SA-JER-DS011-TRJR-480308
1"
LPS
011
071381
101CS1P
2"-LPS-011071383-101CS1P-H
011-US-075
-
-
H
40
LP STEAM
Gas
-
SA-JER-DS011-TRJR-480308
1"
LPS
011
071382
101CS1P
2"-LPS-011071383-101CS1P-H
011-US-076
-
-
H
40
LP STEAM
Gas
SA-JER-DS011-TRJR-480308
2"
LPS
011
071383
101CS1P
2"-LPS-011071303-101CS1P-H
Reducer
-
-
H
50
LP STEAM
SA-JER-DS011-TRJR-480308
1"
LPS
011
071383
101CS1P
Reducer
011-US-077
-
-
H
40
SA-JER-DS011-TRJR-480308
2"
LPS
011
071384
101CS1P
2"-LPS-011071303-101CS1P-H
Reducer
-
-
H
50
SA-JER-DS011-TRJR-480308
1"
LPS
011
071384
101CS1P
Reducer
011-US-078
-
-
H
40
SA-JER-DS011-TRJR-480308
1"
LPS
011
071385
101CS1P
2"-LPS-011071384-101CS1P-H
011-US-080
-
-
H
40
SA-JER-DS011-TRJR-480308
1"
LPS
011
071386
101CS1P
2"-LPS-011071384-101CS1P-H
011-US-081
-
-
H
SA-JER-DS011-TRJR-480309
1"
LPS
011
071387
101CS1P
2"-LPS-011071400-101CS1P-H
011-US-091
-
-
SA-JER-DS011-TRJR-480308
1"
LPS
011
071388
101CS1P
2"-LPS-011071389-101CS1P-H
011-US-082
-
SA-JER-DS011-TRJR-480308
2"
LPS
011
071389
101CS1P
2"-LPS-011071384-101CS1P-H
Reducer
SA-JER-DS011-TRJR-480308
1"
LPS
011
071389
101CS1P
Reducer
SA-JER-DS011-TRJR-480308
1"
LPS
011
071390
101CS1P
SA-JER-DS011-TRJR-480308
1"
LPS
011
071391
101CS1P
SA-JER-DS011-TRJR-480309
2"
LPS
011
071392
SA-JER-DS011-TRJR-480309
1"
LPS
011
SA-JER-DS011-TRJR-480309
1"
LPS
SA-JER-DS011-TRJR-480309
1"
SA-JER-DS011-TRJR-480309
SA-JER-DS011-TRJR-380001
-1.00
-1.00
290.00
290.00
290.0
290.0
-
Page 117 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
INSULATION (NOTE 2)
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480309
1"
LPS
011
071401
101CS1P
Reducer
011-US-096
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071402
101CS1P
2"-LPS-011071412-101CS1P-H
011-US-097
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071403
101CS1P
2"-LPS-011071412-101CS1P-H
011-US-098
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071404
101CS1P
2"-LPS-011071412-101CS1P-H
011-US-100
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071405
101CS1P
2"-LPS-011071412-101CS1P-H
011-US-099
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071406
101CS1P
2"-LPS-011071412-101CS1P-H
011-US-101
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071407
101CS1P
2"-LPS-011071412-101CS1P-H
011-US-105
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071408
101CS1P
2"-LPS-011071412-101CS1P-H
011-US-102
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071409
101CS1P
2"-LPS-011071412-101CS1P-H
011-US-103
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071410
101CS1P
2"-LPS-011071412-101CS1P-H
011-US-104
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
LPS
011
071411
101CS1P
2"-LPS-011071426-101CS1P-H
011-US-107
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS
SA-JER-DS011-TRJR-480309
2"
LPS
011
071412
101CS1P
2"-LPS-011071401-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071412
101CS1P
Reducer
011-US-106
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480315
1"
LPS
011
071413
101CS1P
2"-LPS-011071426-101CS1P-H
011-US-108
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480315
1"
LPS
011
071414
101CS1P
2"-LPS-011071426-101CS1P-H
011-US-109
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480315
1"
LPS
011
071415
101CS1P
2"-LPS-011071426-101CS1P-H
011-US-110
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480201
2"
LPS
011
071416
101CS1P
UC
011-D-0026
-
-
P
25
LP CONDENSATE
Liquid
932
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
ALTERNATIVE DESIGN CONDITIONS: FV @ 290ºC
SA-JER-DS011-TRJR-480201
3/4"
LPS
011
071416
101CS1P
2"-LPS-011071416-101CS1P-P
Plug
-
-
P
25
LP CONDENSATE
Liquid
932
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
ALTERNATIVE DESIGN CONDITIONS: FV @ 290ºC
SA-JER-DS011-TRJR-480309
2"
LPS
011
071417
101CS1P
2"-LPS-011071303-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071417
101CS1P
Reducer
011-US-128
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071418
101CS1P
2"-LPS-011071417-101CS1P-H
011-US-121
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
2"
LPS
011
071419
101CS1P
2"-LPS-011071417-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071419
101CS1P
Reducer
011-US-127
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-1.00
290.00
290.0
290.00 290.00
NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071420
101CS1P
2"-LPS-011071419-101CS1P-H
011-US-126
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071421
101CS1P
2"-LPS-011071417-101CS1P-H
011-US-126
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071422
101CS1P
2"-LPS-011071423-101CS1P-H
011-US-122
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS -
SA-JER-DS011-TRJR-480309
2"
LPS
011
071423
101CS1P
2"-LPS-011071303-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071423
101CS1P
Reducer
011-US-124
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480309
1"
LPS
011
071424
101CS1P
2"-LPS-011071423-101CS1P-H
011-US-123
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480315
1"
LPS
011
071425
101CS1P
1"-LPS-011071438-101CS1P-H
SA-JER-DS011-TRJR-480315
2"
LPS
011
071426
101CS1P
SA-JER-DS011-TRJR-480315
1"
LPS
011
071426
101CS1P
SA-JER-DS011-TRJR-480310
1"
LPS
011
071427
SA-JER-DS011-TRJR-480315
1"
LPS
011
SA-JER-DS011-TRJR-480310
1"
LPS
SA-JER-DS011-TRJR-480310
1"
SA-JER-DS011-TRJR-480315
1"
SA-JER-DS011-TRJR-480310 SA-JER-DS011-TRJR-480315
NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS -
011-US-129
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
2"-LPS-011071303-101CS1P-H
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
Reducer
011-US-111
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-112
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
071428
101CS1P
2"-LPS-011071426-101CS1P-H
011-US-116
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
011
071429
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-130
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
LPS
011
071430
101CS1P
1"-LPS-011071432-101CS1P-H
011-US-118
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
LPS
011
071431
101CS1P
1"-LPS-011071432-101CS1P-H
011-US-120
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
1"
LPS
011
071432
101CS1P
2"-LPS-011071303-101CS1P-H
SA-JER-DS011-TRJR-480315
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
1"
LPS
011
071432
101CS1P
SA-JER-DS011-TRJR-480310
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480315
3/4"
LPS
011
071432
101CS1P
Reducer
011-US-131
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480315
1"
LPS
011
071433
101CS1P
1"-LPS-011071432-101CS1P-H
011-US-119
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480315
1"
LPS
011
071434
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-117
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480315
1"
LPS
011
071435
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-114
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480315
1"
LPS
011
071436
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-113
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480310
1"
LPS
011
071437
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-115
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480315
1"
LPS
011
071438
101CS1P
1"-LPS-011071432-101CS1P-H
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480315
3/4"
LPS
011
071438
101CS1P
Reducer
011-US-132
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071439
101CS1P
2"-LPS-011071310-101CS1P-H
011-US-133
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS -
SA-JER-DS011-TRJR-480306
1"
LPS
011
071440
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-134
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
LPS
011
071441
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-135
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
LPS
011
071442
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-136
-
-
H
40
NITROGEN
Gas
-
5.50
190.00
-
-
7.00
290.00
-
H
11.64
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480314
1"
LPS
011
071443
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-137
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480314
1"
LPS
011
071444
101CS1P
2"-LPS-011071303-101CS1P-H
011-US-138
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480314
1"
LPS
011
071445
101CS1P
2"-LPS-011071348-101CS1P-H
011-US-139
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480308
1"
LPS
011
071446
101CS1P
2"-LPS-011071384-101CS1P-H
011-US-140
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480201
-
LPS
011
071601
101CS1P
011-D-0026
TRIM
-
-
H
-
-
-
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
Visual Test
0.00
D
By Code
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
2"
LPS
011
071601
101CS1P
011-D-0026
Blind flange
-
-
H
40
-
Gas
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
2"
LPS
011
071601
101CS1P
011-LG-0129
011-D-0026
-
-
H
40
-
Gas
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
2"
LPS
011
071601
101CS1P
011-LT-0131
011-D-0026
-
-
H
40
-
Gas
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
2"
LPS
011
071601
101CS1P
011-LT-0130
011-D-0026
-
-
H
40
-
Gas
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
2"
LPS
011
071601
101CS1P
011-D-0026
011-LT-0130
-
-
H
40
-
Gas
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
2"
LPS
011
071601
101CS1P
011-LT-0131
011-D-0026
-
-
H
40
-
Gas
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
2"
LPS
011
071601
101CS1P
011-LG-0129
011-D-0026
-
-
H
40
-
Gas
-
2.00
134.00
-
-
3.50
-1.00
150.00
150.00
-
H
5.25
D
By Code
N
N
N
N
N
N
-
-
290.00 -1.00
290.00
290.0
290.00 290.00
290.00
-1.00
290.00
290.0
290.00
NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS -
NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS
if insulated M or Q
SA-JER-DS011-TRJR-380001
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
Page 118 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7) NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS NORMAL OPERATING TEMPERATURE, 160ºC, CONSIDERED FOR THE INSULATION THICKNESS -
SA-JER-DS011-TRJR-480204
1-1/2"
LPS
011
071701
101CS1P
16"-LPS-011071301-101CS1P-H
011-SM-001-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
1-1/2"
LPS
011
071703
101CS1P
16"-LPS-011071301-101CS1P-H
011-SM-003-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480313
1-1/2"
LPS
011
071704
101CS1P
2"-LPS-011071719-101CS1P-H
011-SM-004-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480313
1-1/2"
LPS
011
071705
101CS1P
2"-LPS-011071706-101CS1P-H
011-SM-005-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480313
2"
LPS
011
071706
101CS1P
4"-LPS-011071712-101CS1P-H
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480313
1-1/2"
LPS
011
071706
101CS1P
Reducer
011-SM-006-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480313
1-1/2"
LPS
011
071707
101CS1P
2"-LPS-011071715-101CS1P-H
011-SM-007-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480313
1-1/2"
LPS
011
071708
101CS1P
2"-LPS-011071709-101CS1P-H
011-SM-008-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480313
2"
LPS
011
071709
101CS1P
4"-LPS-011071712-101CS1P-H
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480313
1-1/2"
LPS
011
071709
101CS1P
Reducer
011-SM-009-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480203
1-1/2"
LPS
011
071710
101CS1P
16"-LPS-011071301-101CS1P-H
011-SM-010-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480313
4"
LPS
011
071712
101CS1P
16"-LPS-011071301-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480313
2"
LPS
011
071712
101CS1P
Reducer
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480313
1-1/2"
LPS
011
071712
101CS1P
Reducer
011-SM-012-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480313
1-1/2"
LPS
011
071713
101CS1P
2"-LPS-011071712-101CS1P-H
011-SM-013-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480203
1-1/2"
LPS
011
071714
101CS1P
2"-LPS-011071743-101CS1P-H
011-SM-014-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480313
2"
LPS
011
071715
101CS1P
4"-LPS-011071712-101CS1P-H
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480313
1-1/2"
LPS
011
071715
101CS1P
Reducer
011-SM-015-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480313
2"
LPS
011
071719
101CS1P
4"-LPS-011071712-101CS1P-H
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480313
1-1/2"
LPS
011
071719
101CS1P
Reducer
011-SM-019-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480313
1-1/2"
LPS
011
071720
101CS1P
2"-LPS-011071719-101CS1P-H
011-SM-020-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480203
1-1/2"
LPS
011
071721
101CS1P
2"-LPS-011071724-101CS1P-H
011-SM-021-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480203
1-1/2"
LPS
011
071722
101CS1P
2"-LPS-011071724-101CS1P-H
011-SM-022-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480203
1-1/2"
LPS
011
071723
101CS1P
2"-LPS-011071724-101CS1P-H
011-SM-023-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480203
2"
LPS
011
071724
101CS1P
16"-LPS-011071301-101CS1P-H
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480203
1-1/2"
LPS
011
071724
101CS1P
Reducer
011-SM-024-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480203
1-1/2"
LPS
011
071725
101CS1P
2"-LPS-011071728-101CS1P-H
011-SM-025-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480203
1-1/2"
LPS
011
071726
101CS1P
2"-LPS-011071728-101CS1P-H
011-SM-026-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480203
1-1/2"
LPS
011
071727
101CS1P
2"-LPS-011071728-101CS1P-H
011-SM-027-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480203
2"
LPS
011
071728
101CS1P
16"-LPS-011071301-101CS1P-H
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480203
1-1/2"
LPS
011
071728
101CS1P
Reducer
011-SM-028-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480203
1-1/2"
LPS
011
071729
101CS1P
2"-LPS-011071730-101CS1P-H
011-SM-029-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480203
2"
LPS
011
071730
101CS1P
16"-LPS-011071301-101CS1P-H
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480203
1-1/2"
LPS
011
071730
101CS1P
Reducer
011-SM-030-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
1-1/2"
LPS
011
071731
101CS1P
2"-LPS-011071732-101CS1P-H
011-SM-031-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
2"
LPS
011
071732
101CS1P
16"-LPS-011071301-101CS1P-H
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
1-1/2"
LPS
011
071732
101CS1P
Reducer
011-SM-032-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480203
1-1/2"
LPS
011
071733
101CS1P
2"-LPS-011071724-101CS1P-H
011-SM-033-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480203
1-1/2"
LPS
011
071734
101CS1P
16"-LPS-011071301-101CS1P-H
011-SM-034-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
1-1/2"
LPS
011
071735
101CS1P
16"-LPS-011071301-101CS1P-H
011-SM-035-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
1-1/2"
LPS
011
071737
101CS1P
16"-LPS-011071301-101CS1P-H
011-SM-037-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
1-1/2"
LPS
011
071738
101CS1P
16"-LPS-011071301-101CS1P-H
011-SM-038-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
1-1/2"
LPS
011
071739
101CS1P
16"-LPS-011071301-101CS1P-H
011-SM-039-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
1-1/2"
LPS
011
071740
101CS1P
16"-LPS-011071301-101CS1P-H
011-SM-040-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
1-1/2"
LPS
011
071741
101CS1P
2"-LPS-011071769-101CS1P-H
011-SM-041-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
1-1/2"
LPS
011
071742
101CS1P
16"-LPS-011071301-101CS1P-H
011-SM-042-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480203
2"
LPS
011
071743
101CS1P
16"-LPS-011071301-101CS1P-H
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480203
1-1/2"
LPS
011
071743
101CS1P
Reducer
011-SM-043-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
1-1/2"
LPS
011
071744
101CS1P
2"-LPS-011071753-101CS1P-H
011-SM-044-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480206
1-1/2"
LPS
011
071751
101CS1P
2"-LPS-011071752-101CS1P-H
011-SM-051-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480206
2"
LPS
011
071752
101CS1P
12"-LPS-011071301-101CS1P-H
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480206
1-1/2"
LPS
011
071752
101CS1P
Reducer
011-SM-052-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
2"
LPS
011
071753
101CS1P
20"-LPS-011071301-101CS1P-H
HEADER
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
1-1/2"
LPS
011
071753
101CS1P
2"-LPS-011071753-101CS1P-H
011-SM-053-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
1-1/2"
LPS
011
071755
101CS1P
2"-LPS-011071753-101CS1P-H
011-SM-055-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
1-1/2"
LPS
011
071757
101CS1P
2"-LPS-011071753-101CS1P-H
011-SM-057-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
1-1/2"
LPS
011
071759
101CS1P
2"-LPS-011071753-101CS1P-H
011-SM-059-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
1-1/2"
LPS
011
071763
101CS1P
20"-LPS-011071301-101CS1P-H
011-SM-063-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
1-1/2"
LPS
011
071764
101CS1P
20"-LPS-011071301-101CS1P-H
011-SM-064-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480206
1-1/2"
LPS
011
071765
101CS1P
12"-LPS-011071301-101CS1P-H
011-SM-065-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480206
1-1/2"
LPS
011
071766
101CS1P
12"-LPS-011071301-101CS1P-H
011-SM-066-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
1-1/2"
LPS
011
071767
101CS1P
16"-LPS-011071301-101CS1P-H
011-SM-067-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
2"
LPS
011
071769
101CS1P
16"-LPS-011071301-101CS1P-H
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
1-1/2"
LPS
011
071769
101CS1P
Reducer
011-SM-069-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480203
1-1/2"
LPS
011
071790
101CS1P
011-SM-073-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
1-1/2"
LPS
011
071791
011-SM-074-LS
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
3/4"
LPS
011
071792
101CS1P
12"-LPS-011017301-101CS1P-H
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480121
1"
LPS
011
071792
101CS1P
SA-JER-DS011-TRJR-480204
011-AT-0003
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
1"
LPS
011
071792
101CS1P
Reducer
SA-JER-DS011-TRJR-480121
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.0
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
2"
LPS
011
076302
101CS1P
20"-LPS-011071301-101CS1P-H
SA-JER-DS011-TRJR-480219
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480219
2"
LPS
011
076302
101CS1P
SA-JER-DS011-TRJR-480204
011-D-0018
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480219
2"
LPS
011
076303
101CS1P
011-D-0018
Reducer
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480219
3/4"
LPS
011
076303
101CS1P
2"-LPS-011076303-101CS1P-H
Plug
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-380001
1-1/2"-LPS-011071730-101CS1PH 1-1/2"-LPS-011071732-101CS1P101CS1P H
Page 119 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
TO
TYPE
INSULATION (NOTE 2)
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480219
2"
LPS
011
076303
101CS1P
2"-LPS-011076303-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480219
3/4"
LPS
011
076303
101CS1P
Reducer
3/4"-LPC-011076301-101CS1P-H
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480219
3/4"
LPS
011
076303
101CS1P
2"-LPS-011076303-101CS1P-H
Plug
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480219
1"
LPS
011
076303
101CS1P
Reducer
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480219
2"
LPS
011
076303
101CS1P
Reducer
2"-LPC-011076301-101CS1P-H
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480204
2"
LPS
011
078301
101CS1P
20"-LPS-011071301-101CS1P-H
SA-JER-DS011-TRJR-480232
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480232
2"
LPS
011
078301
101CS1P
SA-JER-DS011-TRJR-480204
011-D-0014
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480232
3/4"
LPS
011
078301
101CS1P
2"-LPS-011078301-101CS1P-H
Plug
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480232
2"
LPS
011
078302
101CS1P
011-D-0014
Reducer
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480232
3/4"
LPS
011
078302
101CS1P
2"-LPS-011078302-101CS1P-H
Plug
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480232
2"
LPS
011
078302
101CS1P
2"-LPS-011078302-101CS1P-H
Reducer
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480232
3/4"
LPS
011
078302
101CS1P
Reducer
3/4"-LPC-011078301-101CS1P-H
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480232
1"
LPS
011
078302
101CS1P
Reducer
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480232
2"
LPS
011
078302
101CS1P
Reducer
2"-LPC-011078301-101CS1P-H
-
-
H
50
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480232
3/4"
LPS
011
078302
101CS1P
2"-LPS-011078302-101CS1P-H
Plug
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
3/4"
LPS
011
200001
101CS1P
SAMPLE COOLER
Reducer
-
-
N
-
LP STEAM
Gas
-
2.60
60.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
4"
LPS
011
200001
101CS1P
Reducer
Reducer
-
-
N
-
LP STEAM
Gas
-
2.60
60.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
3/4"
LPS
011
200001
101CS1P
Reducer
SO
-
-
N
-
LP STEAM
Gas
-
2.60
60.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
3/4"
LPS
011
200002
101CS1P
3/4"-LPS-011200001-101CS1P-N
Reducer
-
-
N
-
LP STEAM
Gas
-
2.60
60.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
2"
LPS
011
200002
101CS1P
Reducer
2"-CLD-011200318-101CH2S-P
-
-
N
-
LP STEAM
Gas
-
2.60
60.00
-
-
7.00
-1.00
170.00
170.00
-
H
10.50
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480206
1"
LPS
011
200301
101CS1P
12"-LPS-011071301-101CS1P-H
Reducer
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480206
3/4"
LPS
011
200301
101CS1P
Reducer
SA-JER-DS011-TRJR-480274
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
3/4"
LPS
011
200301
101CS1P
SA-JER-DS011-TRJR-480206
3/4"-HFO-011038017-103CS1P-S
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
3/4"
LPS
011
200303
101CS1P
SA-JER-DS011-TRJR-480203
3/4"-HFO-011038011-103CL2P-S
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480203
3/4"
LPS
011
200303
101CS1P
16"-LPS-011071301-101CS1P-H
SA-JER-DS011-TRJR-480274
-
-
H
40
LP STEAM
Gas
-
5.50
190.00
-
-
7.00
-1.00
290.00
290.00
-
H
11.64
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480249
3/4"
LUB
011
171401
106SU0P
011-G-0025-A
API COOLER
-
-
N
-
LIGTH GAS OIL VG 24
Liquid
890
24.50
60.00
-
-
40.00
80.00
6.00
-
H (Own Fluid)
60.00
D
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480249
3/4"
LUB
011
171402
106SU0P
API COOLER
011-G-0025-A
-
-
N
-
LIGTH GAS OIL VG 24
Liquid
890
24.50
45.00
-
-
40.00
80.00
6.00
-
H (Own Fluid)
60.00
D
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1"
LUB
011
405401
101SD0P
011-S-0012-A
Reducer
-
-
N
-
LUBE OIL
Liquid
840
5.00
49.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
3/4"
LUB
011
405401
101SD0P
Reducer
Reducer
-
-
N
-
LUBE OIL
Liquid
840
5.00
49.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480268
1"
LUB
011
405401
101SD0P
SA-JER-DS011-TRJR-480267
Reducer
-
-
N
-
LUBE OIL
Liquid
840
5.00
49.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480268
3/4"
LUB
011
405401
101SD0P
Reducer
011-K-0003
-
-
N
-
LUBE OIL
Liquid
840
5.00
49.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480268
3/4"
LUB
011
405401
101SD0P
3/4"-LUB-011405401-101SD0P-N
011-K-0003
-
-
N
-
LUBE OIL
Liquid
840
5.00
49.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480268
1"
LUB
011
405401
101SD0P
1"-LUB-011405401-101SD0P-N
Reducer
-
-
N
-
LUBE OIL
Liquid
840
5.00
49.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480268
3/4"
LUB
011
405401
101SD0P
Reducer
011-K-0003
-
-
N
-
LUBE OIL
Liquid
840
5.00
49.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480268
3/4"
LUB
011
405401
101SD0P
3/4"-LUB-011405401-101SD0P-N
011-K-0003
-
-
N
-
LUBE OIL
Liquid
840
5.00
49.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1"
LUB
011
405401
101SD0P
Reducer
SA-JER-DS011-TRJR-480268
-
-
N
-
LUBE OIL
Liquid
840
5.00
49.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1"
LUB
011
405401
101SD0P
011-S-0012-B
1"-LUB-011405401-101SD0P-N
-
-
N
-
LUBE OIL
Liquid
840
5.00
49.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480268
1-1/2"
LUB
011
405402
101SD0P
011-K-0003
Reducer
-
-
N
-
LUBE OIL
Liquid
840
0.02
60.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480268
4"
LUB
011
405402
101SD0P
Reducer
Reducer
-
-
N
-
LUBE OIL
Liquid
840
0.02
60.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
3"
LUB
011
405402
101SD0P
SA-JER-DS011-TRJR-480268
011-D-0035
-
-
N
-
LUBE OIL
Liquid
840
0.02
60.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480268
1-1/2"
LUB
011
405402
101SD0P
Reducer
Reducer
-
-
N
-
LUBE OIL
Liquid
840
0.02
60.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480268
3"
LUB
011
405402
101SD0P
Reducer
SA-JER-DS011-TRJR-480267
-
-
N
-
LUBE OIL
Liquid
840
0.02
60.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480268
1-1/2"
LUB
011
405402
101SD0P
011-K-0003
Reducer
-
-
N
-
LUBE OIL
Liquid
840
0.02
60.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480268
4"
LUB
011
405402
101SD0P
Reducer
Reducer
-
-
N
-
LUBE OIL
Liquid
840
0.02
60.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480268
1-1/2"
LUB
011
405402
101SD0P
Reducer
3"-LUB-011405402-101SD0P-N
-
-
N
-
LUBE OIL
Liquid
840
0.02
60.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1"
LUB
011
405403
101SD0P
011-G-0042-A
011-E-0048-A
-
-
N
-
LUBE OIL
Liquid
840
5.40
60.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1"
LUB
011
405403
101SD0P
1"-LUB-011405403-101SD0P-N
011-E-0048-B
-
-
N
-
LUBE OIL
Liquid
840
5.40
60.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1"
LUB
011
405403
101SD0P
1"-LUB-011405403-101SD0P-N
011-PZV-0489
-
-
N
-
LUBE OIL
Liquid
840
5.40
60.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1"
LUB
011
405403
101SD0P
011-G-0042-B
1"-LUB-011405403-101SD0P-N
-
-
N
-
LUBE OIL
Liquid
840
5.40
60.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1"
LUB
011
405403
101SD0P
1"-LUB-011405403-101SD0P-N
011-PZV-0490
-
-
N
-
LUBE OIL
Liquid
840
5.40
60.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1"
LUB
011
405404
101SD0P
1"-LUB-011405403-101SD0P-N
011-TCV-0490
-
-
N
-
LUBE OIL
Liquid
840
5.40
60.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1-1/2"
LUB
011
405405
101CS1P
011-D-0035
011-G-0042-A
-
-
N
-
LUBE OIL
Liquid
840
0.02
60.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480267
1-1/2"
LUB
011
405406
101CS1P
011-D-0035
011-G-0042-B
-
-
N
-
LUBE OIL
Liquid
840
0.02
60.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480267
1"
LUB
011
405407
101CS1P
011-PZV-0489
011-D-0035
-
-
N
-
LUBE OIL
Liquid
840
5.40
60.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1"
LUB
011
405408
101CS1P
011-PZV-0490
011-D-0035
-
-
N
-
LUBE OIL
Liquid
840
5.40
60.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1"
LUB
011
405409
101SD0P
011-E-0048-A
Reducer
-
-
N
-
LUBE OIL
Liquid
840
5.00
49.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1/2"
LUB
011
405409
101SD0P
Reducer
011-D-0035
-
-
N
-
LUBE OIL
Liquid
840
5.00
49.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1"
LUB
011
405409
101SD0P
011-E-0048-B
1"-LUB-011405409-101SD0P-N
-
-
N
-
LUBE OIL
Liquid
840
5.00
49.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1"
LUB
011
405409
101SD0P
1"-LUB-011405409-101SD0P-N
Reducer
-
-
N
-
LUBE OIL
Liquid
840
5.00
49.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
4"
LUB
011
405409
101SD0P
Reducer
Reducer
-
-
N
-
LUBE OIL
Liquid
840
5.00
49.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1"
LUB
011
405409
101SD0P
Reducer
011-S-0012-A
-
-
N
-
LUBE OIL
Liquid
840
5.00
49.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1"
LUB
011
405409
101SD0P
1"-LUB-011405409-101SD0P-N
011-S-0012-B
-
-
N
-
LUBE OIL
Liquid
840
5.00
49.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1"
LUB
011
405409
101SD0P
1"-LUB-011405409-101SD0P-N
Reducer
-
-
N
-
LUBE OIL
Liquid
840
5.00
49.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
Reducer
3/4"-OLW-011405301-101CS1PN
-
-
N
-
LUBE OIL
Liquid
840
5.00
49.00
-
-
9.00
80.00
-
H (Own Fluid)
13.50
D
By Vendor
By Vendor
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
3/4"
LUB
011
405409
101SD0P
SA-JER-DS011-TRJR-480254
1-1/2"
LUB
011
446401
101SD0P
N2
SA-JER-DS011-TRJR-480255
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
NO
E
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480255
1-1/2"
LUB
011
446401
101SD0P
SA-JER-DS011-TRJR-480254
LN08
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480255
1-1/2"
LUB
011
446401
101SD0P
1-1/2"-LUB-011446401-101SD0PN
LN08
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480255
3"
LUB
011
446402
101SD0P
LNOB
Reducer
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480255
6"
LUB
011
446402
101SD0P
Reducer
SA-JER-DS011-TRJR-480254
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480255
3"
LUB
011
446402
101SD0P
LNOB
Reducer
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480254
6"
LUB
011
446402
101SD0P
SA-JER-DS011-TRJR-480255
011-D-0036
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00 N
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480255
6"
LUB
011
446402
101SD0P
Reducer
6"-LUB-011446402-101SD0P-N
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480254
2"
LUB
011
446403
101SDOP
2"-LUB-011446403-101SDOP-N
011-G-0038-B
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
2"
LUB
011
446404
101SD0P
2"-LUB-011446404-101SD0P-N
011-G-0038-A
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
1-1/2"
LUB
011
446405
101SD0P
011-G-0038-A
Reducer
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.50
-
-
12.00
150.00
-
H (Own Fluid)
18.01
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
3"
LUB
011
446405
101SD0P
Reducer
Reducer
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.50
-
-
12.00
150.00
-
H (Own Fluid)
18.01
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
1-1/2"
LUB
011
446405
101SD0P
Reducer
011-E-0044-A
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.50
-
-
12.00
150.00
-
H (Own Fluid)
18.01
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
1-1/2"
LUB
011
446405
101SD0P
1-1/2"-LUB-011446405-101SD0PN
011-E-0044-B
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.50
-
-
12.00
150.00
-
H (Own Fluid)
18.01
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
1-1/2"
LUB
011
446405
101SD0P
011-G-0038-B
1-1/2"-LUB-011446405-101SD0PN
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.50
-
-
12.00
150.00
-
H (Own Fluid)
18.01
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
1-1/2"
LUB
011
446406
101SD0P
011-E-0044-A
Reducer
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
3"
LUB
011
446406
101SD0P
Reducer
Reducer
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
1-1/2"
LUB
011
446406
101SD0P
Reducer
011-S-0008-A
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
1-1/2"
LUB
011
446406
101SD0P
011-E-0044-B
1-1/2"-LUB-011446406-101SD0PN
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
1-1/2"
LUB
011
446406
011-S-0008-B
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
1-1/2"
LUB
011
446407
011-TCV-0633
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.50
-
-
12.00
150.00
-
H (Own Fluid)
18.01
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
1-1/2"
LUB
011
446408
Reducer
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.50
-
-
12.00
150.00
-
H (Own Fluid)
18.01
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
3/4"
LUB
011
446408
1-1/2"-LUB-011446406-101SD0PN 1-1/2"-LUB-011446405-101SD0P101SD0P N 1-1/2"-LUB-011446405-101SD0P101SD0P N 101SD0P Reducer
011-PZV-0603
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.50
-
-
12.00
150.00
-
H (Own Fluid)
18.01
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
1-1/2"
LUB
011
446409
101SD0P
1-1/2"-LUB-011446405-101SD0PN
Reducer
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.50
-
-
12.00
150.00
-
H (Own Fluid)
18.01
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
3/4"
LUB
011
446409
101SD0P
Reducer
011-PZV-0602
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.50
-
-
12.00
150.00
-
H (Own Fluid)
18.01
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-380001
101SD0P
Page 120 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
INSULATION (NOTE 2)
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480254
1"
LUB
011
446410
101SD0P
011-PZV-0602
011-D-0036
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.50
-
-
12.00
150.00
-
H (Own Fluid)
18.01
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
1"
LUB
011
446411
101SD0P
011-PZV-0603
011-D-0036
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.50
-
-
12.00
150.00
-
H (Own Fluid)
18.01
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
1"
LUB
011
446411
101SD0P
LUBE OIL PURIFIER SUCTION
011-D-0036
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
1-1/2"
LUB
011
446412
101SD0P
1-1/2"-LUB-011446405-101SD0PN
Reducer
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.50
-
-
12.00
150.00
-
H (Own Fluid)
18.01
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
1"
LUB
011
446412
101SD0P
Reducer
Reducer
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.50
-
-
12.00
150.00
-
H (Own Fluid)
18.01
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
1-1/2"
LUB
011
446412
101SD0P
Reducer
011-D-0036
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.50
-
-
12.00
150.00
-
H (Own Fluid)
18.01
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
1/2"
LUB
011
446413
101SD0P
011-S-0008-A
N2
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480254
1/2"
LUB
011
446413
101SD0P
011-S-0008-B
1/2"-LUB-011446413-101SD0P-N
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480255
1-1/2"
LUB
011
446414
101SD0P
LN08
011-GM-0001-A
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480255
1-1/2"
LUB
011
446415
101SD0P
LN08
011-GM-0001-B
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480255
3"
LUB
011
446416
101SD0P
011-GM-0001-B
LNOB
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480255
3"
LUB
011
446417
101SD0P
011-GM-0001-A
LNOB
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
1-1/2"
LUB
011
450401
101SD0P
N2
SA-JER-DS011-TRJR-480257
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00 N
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480257
1-1/2"
LUB
011
450401
101SD0P
SA-JER-DS011-TRJR-480256
LN0B
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480257
1-1/2"
LUB
011
450401
101SD0P
1-1/2"-LUB-011450401-101SD0PN
LN0B
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480257
3"
LUB
011
450402
101SD0P
LN0B
Reducer
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480257
6"
LUB
011
450402
101SD0P
Reducer
SA-JER-DS011-TRJR-480256
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480257
3"
LUB
011
450402
101SD0P
LN0B
Reducer
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480256
6"
LUB
011
450402
101SD0P
SA-JER-DS011-TRJR-480257
011-D-0037
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00 N
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480257
6"
LUB
011
450402
101SD0P
Reducer
6"-LUB-011450402-101SD0P-N
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480257
1-1/2"
LUB
011
450403
101SD0P
LN0B
011-GM-0002-A
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480257
3"
LUB
011
450404
101SD0P
011-GM-0002-A
LN0B
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480257
1-1/2"
LUB
011
450405
101SD0P
LN0B
011-GM-0002-B
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480257
3"
LUB
011
450406
101SD0P
011-GM-0002-B
LN0B
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
1-1/2"
LUB
011
450407
101SD0P
011-S-0009-A
N2
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
1-1/2"
LUB
011
450407
101SD0P
011-S-0009-B
1-1/2"-LUB-011450407-101SD0PN
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
1-1/2"
LUB
011
450408
101SD0P
011-E-0045-A
Reducer
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
3"
LUB
011
450408
101SD0P
Reducer
Reducer
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
1-1/2"
LUB
011
450408
101SD0P
Reducer
011-S-0009-A
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
1-1/2"
LUB
011
450408
101SD0P
011-E-0045-B
1-1/2"-LUB-011450408-101SD0PN
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
1-1/2"
LUB
011
450408
101SD0P
011-S-0009-B
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
1-1/2"
LUB
011
450409
011-TCV-0683
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
2"
LUB
011
450411
101SDOP 1/2"-LUB-011450411-101SDOP-N
011-G-0039-B
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
2"
LUB
011
450412
101SD0P
1/2"-LUB-011450412-101SD0P-N
011-G-0039-A
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
1-1/2"
LUB
011
450413
101SD0P
1-1/2"-LUB-011450417-101SD0PN
Reducer
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
1"
LUB
011
450413
101SD0P
Reducer
Reducer
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
1-1/2"
LUB
011
450413
101SD0P
Reducer
011-D-0037
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
1-1/2"
LUB
011
450414
101SD0P
011-G-0039-B
1-1/2"-LUB-011450413-101SD0PN
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
1-1/2"
LUB
011
450415
101SD0P
1-1/2"-LUB-011450414-101SD0PN
Reducer
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
3/4"
LUB
011
450415
101SD0P
Reducer
011-PZV-0653
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
1"
LUB
011
450416
101SD0P
011-PZV-0653
011-D-0037
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
1-1/2"
LUB
011
450417
101SD0P
011-G-0039-A
Reducer
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
3"
LUB
011
450417
101SD0P
Reducer
Reducer
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
1-1/2"
LUB
011
450417
101SD0P
Reducer
011-E-0045-A
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
1-1/2"
LUB
011
450417
101SD0P
011-E-0045-B
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
1-1/2"
LUB
011
450418
Reducer
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
3/4"
LUB
011
450418
101SD0P
Reducer
011-PZV-0652
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480256
1"
LUB
011
450419
101SD0P
011-PZV-0652
011-D-0037
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
1-1/2"
LUB
011
460401
101SD0P
N2
SA-JER-DS011-TRJR-480259
-
-
N
-
LUBE OIL
Liquid
840
8.70
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00 N
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480259
1-1/2"
LUB
011
460401
101SD0P
LN08
-
-
N
-
LUBE OIL
Liquid
840
8.70
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
NO
E
Y
N
N
N
N
N
-
-
LN08
-
-
N
-
LUBE OIL
Liquid
840
8.70
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
NO
E
Y
N
N
N
N
N
-
-
1-1/2"-LUB-011450408-101SD0PN 1-1/2"-LUB-011450417-101SD0P101SD0P N
1-1/2"-LUB-011450417-101SD0PN 1-1/2"-LUB-011450417-101SD0P101SD0P N
SA-JER-DS011-TRJR-480258
SA-JER-DS011-TRJR-480259
1-1/2"
LUB
011
460401
SA-JER-DS011-TRJR-480259
3"
LUB
011
460402
1-1/2"-LUB-011460401-101SD0P101SD0P N 101SD0P LNOB
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
NO
E
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480259
6"
LUB
011
460402
101SD0P
Reducer
SA-JER-DS011-TRJR-480258
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
NO
E
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480259
3"
LUB
011
460402
101SD0P
LNOB
6"-LUB-011460402-101SD0P-N
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480258
6"
LUB
011
460402
101SD0P
SA-JER-DS011-TRJR-480259
011-D-0038
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00 N
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480258
1-1/2"
LUB
011
460403
101SD0P
011-S-0010-A
N2
-
-
N
-
LUBE OIL
Liquid
840
8.70
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
1-1/2"
LUB
011
460403
101SD0P
011-S-0010-B
1-1/2"-LUB-011460403-101SD0PN
-
-
N
-
LUBE OIL
Liquid
840
8.70
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
1-1/2"
LUB
011
460404
101SD0P
011-E-0046-B
Reducer
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
3"
LUB
011
460404
101SD0P
Reducer
Reducer
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
1-1/2"
LUB
011
460404
101SD0P
Reducer
011-S-0010-A
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
1-1/2"
LUB
011
460404
101SD0P
011-E-0046-A
1-1/2"-LUB-011460404-101SD0PN
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
1-1/2"
LUB
011
460404
101SD0P
011-S-0010-B
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
1-1/2"
LUB
011
460405
011-TCV-0733
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
1-1/2"
LUB
011
460406
1-1/2"-LUB-011460404-101SD0PN 1-1/2"-LUB-011460406-101SD0P101SD0P N 101SD0P 011-G-0040-A
Reducer
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
3"
LUB
011
460406
101SD0P
Reducer
Reducer
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
1-1/2"
LUB
011
460406
101SD0P
Reducer
011-E-0046-B
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
011-E-0046-A
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
Reducer
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
Reducer
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
Reducer
-
-
SA-JER-DS011-TRJR-480258
1-1/2"
LUB
011
460406
SA-JER-DS011-TRJR-480258
1-1/2"
LUB
011
460407
SA-JER-DS011-TRJR-480258
1"
LUB
011
460407
1-1/2"-LUB-011460406-101SD0P101SD0P N 1-1/2"-LUB-011460406-101SD0P101SD0P N 101SD0P Reducer
SA-JER-DS011-TRJR-480258
1-1/2"
LUB
011
460407
101SD0P
Reducer
011-D-0038
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
1-1/2"
LUB
011
460408
101SD0P
011-G-0040-B
1-1/2"-LUB-011460406-101SD0PN
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
2"
LUB
011
460409
101SD0P
011-D-0038
011-G-0040-A
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
2"
LUB
011
460410
101SDOP
011-D-0038
011-G-0040-B
-
-
N
-
LUBE OIL
Liquid
840
0.02
49.00
-
-
12.00
50.00
-
-
-
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
1-1/2"
LUB
011
460411
101SD0P
1-1/2"-LUB-011460408-101SD0PN
Reducer
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
3/4"
LUB
011
460411
101SD0P
Reducer
011-PZV-0703
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
1-1/2"
LUB
011
460412
101SD0P
1-1/2"-LUB-011460406-101SD0PN
Reducer
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
3/4"
LUB
011
460412
101SD0P
Reducer
011-PZV-0702
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
1"
LUB
011
460413
101SD0P
011-PZV-0703
011-D-0038
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480258
1"
LUB
011
460414
101SD0P
011-PZV-0702
011-D-0038
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480259
1-1/2"
LUB
011
460416
101SD0P
LN08
011-GM-0004-A
-
-
N
-
LUBE OIL
Liquid
840
8.70
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480259
3"
LUB
011
460417
101SD0P
011-GM-0004-A
LNOB
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480259
1-1/2"
LUB
011
460418
101SD0P
LN08
011-GM-0004-B
-
-
N
-
LUBE OIL
Liquid
840
8.70
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480259
3"
LUB
011
460419
101SD0P
011-GM-0004-B
LNOB
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480260
1-1/2"
LUB
011
525401
101SD0P
N2
SA-JER-DS011-TRJR-480261
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00 N
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480261
1-1/2"
LUB
011
525401
101SD0P
SA-JER-DS011-TRJR-480260
LN08
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
D
Page 121 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480261
1-1/2"
LUB
011
525401
101SD0P
1-1/2"-LUB-011525401-101SD0PN
LN08
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480261
3"
LUB
011
525402
101SD0P
LNOB
Reducer
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
NO
E
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480261
6"
LUB
011
525402
101SD0P
Reducer
SA-JER-DS011-TRJR-480260
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
NO
E
Y
N
N
N
N
N
-
SA-JER-DS011-TRJR-480261
3"
LUB
011
525402
101SD0P
LNOB
6"-LUB-011525402-101SD0P-N
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
SA-JER-DS011-TRJR-480260
6"
LUB
011
525402
101SD0P
SA-JER-DS011-TRJR-480261
011-D-0039
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00 N
SA-JER-DS011-TRJR-480261
1-1/2"
LUB
011
525403
101SD0P
LN08
011-GM-0017-A
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
SA-JER-DS011-TRJR-480261
3"
LUB
011
525404
101SD0P
011-GM-0017-A
LNOB
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
SA-JER-DS011-TRJR-480261
1-1/2"
LUB
011
525405
101SD0P
LN08
011-GM-0017-B
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
H (Own Fluid)
SA-JER-DS011-TRJR-480260
1-1/2"
LUB
011
525406
101SD0P
011-S-0011-A
N2
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
-
SA-JER-DS011-TRJR-480260
1-1/2"
LUB
011
525406
101SD0P
011-S-0011-B
1-1/2"-LUB-011525406-101SD0PN
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
100.00
SA-JER-DS011-TRJR-480260
1-1/2"
LUB
011
525407
101SD0P
011-E-0047-A
Reducer
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
12.00
SA-JER-DS011-TRJR-480260
3"
LUB
011
525407
101SD0P
Reducer
Reducer
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
-
SA-JER-DS011-TRJR-480260
1-1/2"
LUB
011
525407
101SD0P
Reducer
011-S-0011-A
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
-
011-E-0047-B
1-1/2"-LUB-011525407-101SD0PN
-
-
N
-
LUBE OIL
Liquid
840
5.00
50.00
011-S-0011-B
-
-
N
-
LUBE OIL
Liquid
840
5.00
011-TCV-0783
-
-
N
-
LUBE OIL
Liquid
840
Reducer
-
-
N
-
LUBE OIL
Liquid
Reducer
-
-
N
-
LUBE OIL
011-E-0047-A
-
-
N
-
011-E-0047-B
-
-
N
Reducer
-
-
Reducer
-
SA-JER-DS011-TRJR-480260
1-1/2"
LUB
011
525407
101SD0P
SA-JER-DS011-TRJR-480260
1-1/2"
LUB
011
525407
101SD0P
SA-JER-DS011-TRJR-480260
1-1/2"
LUB
011
525408
SA-JER-DS011-TRJR-480260
1-1/2"
LUB
011
525409
1-1/2"-LUB-011525407-101SD0PN 1-1/2"-LUB-011525409-101SD0P101SD0P N 101SD0P 011-G-0041-A
SA-JER-DS011-TRJR-480260
3"
LUB
011
525409
101SD0P
SA-JER-DS011-TRJR-480260
1-1/2"
LUB
011
525409
101SD0P
Reducer Reducer
1-1/2"-LUB-011525409-101SD0P101SD0P N 1-1/2"-LUB-011525409-101SD0P101SD0P N
-
NO
E
Y
N
N
N
N
N
-
-
NO
E
Y
N
N
N
N
N
-
-
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480260
1-1/2"
LUB
011
525409
SA-JER-DS011-TRJR-480260
1-1/2"
LUB
011
525410
SA-JER-DS011-TRJR-480260
1"
LUB
011
525410
101SD0P
Reducer
SA-JER-DS011-TRJR-480260
1-1/2"
LUB
011
525410
101SD0P
Reducer
011-D-0039
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480260
1-1/2"
LUB
011
525411
101SD0P
011-G-0041-B
1-1/2"-LUB-011525409-101SD0PN
SA-JER-DS011-TRJR-480260
2"
LUB
011
525412
101SD0P
2"-LUB-011525412-101SD0P-N
011-G-0041-A
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480260
2"
LUB
011
525413
101SDOP
2"-LUB-011525413-101SDOP-N
011-G-0041-B
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480260
1-1/2"
LUB
011
525414
101SD0P
1-1/2"-LUB-011525411-101SD0PN
Reducer
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480260
3/4"
LUB
011
525414
101SD0P
Reducer
011-PZV-0753
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480260
1-1/2"
LUB
011
525415
101SD0P
1-1/2"-LUB-011525409-101SD0PN
Reducer
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480260
3/4"
LUB
011
525415
101SD0P
Reducer
011-PZV-0752
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480260
1"
LUB
011
525416
101SD0P
011-PZV-0753
011-D-0039
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480260
1"
LUB
011
525417
101SD0P
011-PZV-0752
011-D-0039
-
-
N
-
LUBE OIL
Liquid
840
8.70
55.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480260
1"
LUB
011
525418
101SD0P
LUBE OIL SUCTION
011-D-0039
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480261
3"
LUB
011
525419
101SD0P
011-GM-0017-B
LNOB
-
-
N
-
LUBE OIL
Liquid
840
0.02
50.00
-
-
12.00
100.00
-
H (Own Fluid)
18.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480139
2"
MPC
011
028301
103CS1P
2"-MPC-011028305-103CS1P-H
SA-JER-DS011-TRJR-480203
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480139
3/4"
MPC
011
028301
103CS1P
3/4"-MPC-011028305-103CS1PH
Reducer
-
-
H
40
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480139
2"
MPC
011
028301
103CS1P
Reducer
2"-MPC-011028301-103CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
2"
MPC
011
028301
103CS1P
SA-JER-DS011-TRJR-480139
3"-MPC-011071301-103CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480139
2"
MPC
011
028305
103CS1P
011-D-0019
Reducer
-
-
H
65
MP CONDENSATE
Liquid/Gas Mixture
882.7
16.50
250.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480139
3/4"
MPC
011
028305
103CS1P
Reducer
3/4"-MPC-011028301-103CS1P-H
-
-
H
40
MP CONDENSATE
Liquid/Gas Mixture
882.7
16.50
250.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480139
3/4"
MPC
011
028305
103CS1P
2"-MPC-011028305-103CS1P-H
Plug
-
-
H
40
MP CONDENSATE
Liquid/Gas Mixture
882.7
16.50
250.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480139
2"
MPC
011
028305
103CS1P
2"-MPC-011028305-103CS1P-H
Reducer
-
-
H
65
MP CONDENSATE
Liquid/Gas Mixture
882.7
16.50
250.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480139
2"
MPC
011
028305
103CS1P
2"-MPC-011028305-103CS1P-H
Blind flange
-
-
H
65
MP CONDENSATE
Liquid/Gas Mixture
882.7
16.50
250.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480139
3/4"
MPC
011
028305
103CS1P
2"-MPC-011028305-103CS1P-H
Plug
-
-
H
40
MP CONDENSATE
Liquid/Gas Mixture
882.7
16.50
250.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480139
1"
MPC
011
028305
103CS1P
Reducer
Reducer
-
-
H
40
MP CONDENSATE
Liquid/Gas Mixture
882.7
16.50
250.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480139
2"
MPC
011
028305
103CS1P
Reducer
2"-MPC-011028301-103CS1P-H
-
-
H
65
MP CONDENSATE
Liquid/Gas Mixture
882.7
16.50
250.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480139
3/4"
MPC
011
028305
103CS1P
2"-MPC-011028305-103CS1P-H
Plug
-
-
H
40
MP CONDENSATE
Liquid/Gas Mixture
882.7
16.50
250.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480084
2"
MPC
011
032301
103CS1P
2"-MPS-011032302-103CS1P-H
SA-JER-DS011-TRJR-480203
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480084
3/4"
MPC
011
032301
103CS1P 3/4"-MPS-011032302-103CS1P-H
Reducer
-
-
H
40
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480084
2"
MPC
011
032301
103CS1P
Reducer
2"-MPC-011032301-103CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
2"
MPC
011
032301
103CS1P
SA-JER-DS011-TRJR-480084
3"-MPC-011071301-103CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
3"
MPC
011
071301
103CS1P
HEADER
SA-JER-DS011-TRJR-480205
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
3"
MPC
011
071301
103CS1P
SA-JER-DS011-TRJR-480203
SA-JER-DS011-TRJR-480313
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480313
3"
MPC
011
071301
103CS1P
SA-JER-DS011-TRJR-480205
SA-JER-DS011-TRJR-480204
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480204
3"
MPC
011
071301
103CS1P
SA-JER-DS011-TRJR-480313
SA-JER-DS011-TRJR-480202
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480202
3"
MPC
011
071301
103CS1P
SA-JER-DS011-TRJR-480204
3"-MPC-011071301-103CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480202
3"
MPC
011
071301
103CS1P
HEADER
SA-JER-DS011-TRJR-480206
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480206
3"
MPC
011
071301
103CS1P
SA-JER-DS011-TRJR-480202
HEADER
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.0
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480202
3"
MPC
011
071302
103CS1P
3"-MPC-011071301-103CS1P-H
SA-JER-DS011-TRJR-480201
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480201
3"
MPC
011
071302
103CS1P
SA-JER-DS011-TRJR-480202
Reducer
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.6
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7.
SA-JER-DS011-TRJR-480201
3/4"
MPC
011
071302
103CS1P
011-PI-0420
3"-MPC-011071302-103CS1P-H
-
-
H
40
MP CONDENSATE
Liquid/Gas Mixture
882.6
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7.
SA-JER-DS011-TRJR-480201
4"
MPC
011
071302
103CS1P
Reducer
4"-LPC-011071303-101CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.6
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7.
SA-JER-DS011-TRJR-480203
2"
MPC
011
071304
103CS1P
HEADER
3"-MPC-011071301-103CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.0
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480206
1-1/2"
MPC
011
071701
103CS1P
011-RM-001-MC
3"-MPC-011071301-103CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.0
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480206
1-1/2"
MPC
011
071702
103CS1P
011-RM-002-MC
Reducer
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.0
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480206
2"
MPC
011
071702
103CS1P
Reducer
3"-MPC-011071301-103CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.0
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480206
1-1/2"
MPC
011
071703
103CS1P
011-RM-003-MC
Reducer
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.0
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480206
2"
MPC
011
071703
103CS1P
Reducer
2"-MPC-011071702-103CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.0
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480206
1-1/2"
MPC
011
071704
103CS1P
011-RM-004-MC
2"-MPC-011071702-103CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.0
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480202
1-1/2"
MPC
011
071705
103CS1P
011-RM-005-MC
3"-MPC-011071301-103CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.0
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480202
1-1/2"
MPC
011
071706
103CS1P
011-RM-006-MC
3"-MPC-011071301-103CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.0
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480202
1-1/2"
MPC
011
071707
103CS1P
011-RM-007-MC
3"-MPC-011071301-103CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.0
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
MPC
011
071708
103CS1P
011-RM-008-MC
3"-MPC-011071301-103CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.0
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
MPC
011
071709
103CS1P
011-RM-009-MC
3"-MPC-011071301-103CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.0
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
MPC
011
071710
103CS1P
011-RM-010-MC
3"-MPC-011071301-103CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.0
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
MPC
011
071711
103CS1P
011-RM-011-MC
3"-MPC-011071301-103CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.0
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480205
1-1/2"
MPC
011
071712
103CS1P
011-RM-012-MC
3"-MPC-011071301-103CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
1-1/2"
MPC
011
071713
103CS1P
011-RM-013-MC
Reducer
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.0
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
2"
MPC
011
071713
103CS1P
Reducer
3"-MPC-011071301-103CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.0
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
1-1/2"
MPC
011
071714
103CS1P
011-RM-014-MC
3"-MPC-011071301-103CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.0
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480203
1-1/2"
MPC
011
071715
103CS1P
011-RM-015-MC
2"-MPC-011071713-103CS1P-H
-
-
H
50
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.0
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480290
1"
MPC
011
230301
103CS1P
1"-MPS-011230302-103CS1P-H
SA-JER-DS011-TRJR-480202
-
-
H
40
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480290
1"
MPC
011
230301
103CS1P
1"-MPC-011230301-103CS1P-H
Reducer
-
-
H
40
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480290
3/4"
MPC
011
230301
103CS1P
Reducer
3/4"-MPS-011230302-103CS1P-H
-
-
H
40
MP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480202
1"
MPC
011
230301
103CS1P
SA-JER-DS011-TRJR-480290
3"-MPC-011071301-103CS1P-H
-
-
H
40
LP CONDENSATE
Liquid/Gas Mixture
882.7
10.00
184.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480020
8"
MPS
011
011002
101CS1P
8"-MPS-011011302-103CS1P-H
Reducer
-
-
H
100
MP STEAM
Gas
-
3.90
270.00
-
-
5.30
-1.00
278.00
350.00
-
H
8.65
NFS
By Code
N or Q
Y
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@350ºC. NOTE 10
SA-JER-DS011-TRJR-480020
6"
MPS
011
011002
101CS1P
Reducer
011-C-0001
-
-
H
100
MP STEAM
Gas
-
3.90
270.00
-
-
5.30
-1.00
278.00
350.00
-
H
8.65
NFS
By Code
N or Q
Y
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@350ºC. NOTE 10
SA-JER-DS011-TRJR-480020
8"
MPS
011
011002
101CS1P
8"-MPS-011011002-101CS1P-H
Reducer
-
-
H
100
MP STEAM
Gas
-
3.90
270.00
-
-
5.30
-
H
8.65
NFS
By Code
N or Q
Y
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@350ºC. NOTE 10
SA-JER-DS011-TRJR-380001
278.00
Page 122 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
(NOTE 3)
(NOTE 4)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC) 278.00
TEST CONDITIONS
(ºC)
MEDIUM (NOTE 5)
FLUID CATEGORY (ASME B.31.3)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480020
6"
MPS
011
011002
101CS1P
Reducer
011-C-0001
-
-
H
100
MP STEAM
Gas
-
3.90
270.00
-
-
5.30
-
H
8.65
NFS
By Code
N or Q
Y
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: FV@350ºC. NOTE 10
SA-JER-DS011-TRJR-480206
4"
MPS
011
011301
103CS1P
12"-MPS-011071302-103CS1P-H
SA-JER-DS011-TRJR-480020
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480020
4"
MPS
011
011301
103CS1P
SA-JER-DS011-TRJR-480206
011-C-0001
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480020
2"
MPS
011
011301
103CS1P
UC
4"-MPS-011011301-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480020
3/4"
MPS
011
011301
103CS1P
4"-MPS-011011301-103CS1P-H
Blind flange
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480206
6"
MPS
011
011302
103CS1P
12"-MPS-011071302-103CS1P-H
SA-JER-DS011-TRJR-480142
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480142
6"
MPS
011
011302
103CS1P
SA-JER-DS011-TRJR-480206
Reducer
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480142
3/4"
MPS
011
011302
103CS1P
6"-MPS-011011302-103CS1P-H
Plug
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480142
1/2"
MPS
011
011302
103CS1P
011-FE-0007
011-FT-0007
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480142
1/2"
MPS
011
011302
103CS1P
011-FE-0007
011-FT-0007
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480142
6"
MPS
011
011302
103CS1P
6"-MPS-011011302-103CS1P-H
Reducer
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480142
2"
MPS
011
011302
103CS1P
Reducer
2"-MPS-011011302-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480142
3"
MPS
011
011302
103CS1P
Reducer
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480142
8"
MPS
011
011302
103CS1P
Reducer
8"-MPS-011011302-103CS1P-H
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480142
3/4"
MPS
011
011302
103CS1P
8"-MPS-011011302-103CS1P-H
Plug
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480142
8"
MPS
011
011302
103CS1P
8"-MPS-011011302-103CS1P-H
SA-JER-DS011-TRJR-480020
-
-
H
100
MP STEAM
Gas
-
3.90
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480142
8"
MPS
011
011302
103CS1P
Reducer
8"-MPS-011011302-103CS1P-H
-
-
H
100
MP STEAM
Gas
-
3.90
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480142
2"
MPS
011
011302
103CS1P
2"-MPS-011011302-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
3.90
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480142
4"
MPS
011
011302
103CS1P
6"-MPS-011011302-103CS1P-H
HEADER
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480142
3/4"
MPS
011
011302
103CS1P
HEADER
Plug
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480142
8"
MPS
011
011302
103CS1P
8"-MPS-011011302-103CS1P-H
HEADER
-
-
H
100
MP STEAM
Gas
-
3.90
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480142
3/4"
MPS
011
011302
103CS1P
HEADER
Plug
-
-
H
65
MP STEAM
Gas
-
3.90
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480020
8"
MPS
011
011302
103CS1P
SA-JER-DS011-TRJR-480142
8"-MPS-011011002-101CS1P-H
-
-
H
100
MP STEAM
Gas
-
3.90
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480142
4"
MPS
011
011304
103CS1P
8"-MPS-011011302-103CS1P-H
4"-MPS-011011306-101CS1P-H
-
-
H
65
MP STEAM
Gas
-
3.90
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480142
4"
MPS
011
011306
101CS1P
4"-MPS-011011304-103CS1P-H
011-Y-0001
-
-
H
65
MP STEAM
Gas
-
3.00
270.00
-
-
4.00
-1.00
350.00
350.00
-
H
7.11
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480205
8"
MPS
011
016301
103CS1P
12"-MPS-011071302-103CS1P-H
SA-JER-DS011-TRJR-480030
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480030
8"
MPS
011
016301
103CS1P
SA-JER-DS011-TRJR-480205
8"-MPS-011016301-103CS1P-H
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480030
6"
MPS
011
016301
103CS1P
8"-MPS-011016301-103CS1P-H
HEADER
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480030
3/4"
MPS
011
016301
103CS1P
HEADER
Plug
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480030
8"
MPS
011
016301
103CS1P
8"-MPS-011016301-103CS1P-H
SA-JER-DS011-TRJR-480031
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480031
8"
MPS
011
016301
103CS1P
SA-JER-DS011-TRJR-480030
SA-JER-DS011-TRJR-480032
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480032
8"
MPS
011
016301
103CS1P
SA-JER-DS011-TRJR-480031
SA-JER-DS011-TRJR-480033
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480033
8"
MPS
011
016301
103CS1P
SA-JER-DS011-TRJR-480032
Reducer
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480033
6"
MPS
011
016301
103CS1P
Reducer
6"-CRU-011017008-103CL2P-H
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480030
6"
MPS
011
016302
103CS1P
8"-MPS-011016301-103CS1P-H
6"-CRU-011016001-103CL2P-H
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480030
6"
MPS
011
016304
103CS1P
8"-MPS-011016301-103CS1P-H
6"-CRU-011017003-103CL2P-H
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480031
6"
MPS
011
016306
103CS1P
8"-MPS-011016301-103CS1P-H
6"-CRU-011017004-103CL2P-H
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480031
6"
MPS
011
016308
103CS1P
8"-MPS-011016301-103CS1P-H
6"-CRU-011017005-103CL2P-H
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480032
6"
MPS
011
016310
103CS1P
8"-MPS-011016301-103CS1P-H
6"-CRU-011017006-103CL2P-H
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480032
6"
MPS
011
016312
103CS1P
8"-MPS-011016301-103CS1P-H
6"-CRU-011017007-103CL2P-H
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480033
6"
MPS
011
016314
103CS1P
8"-MPS-011016301-103CS1P-H
6"-CRU-011017009-103CL2P-H
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480204
4"
MPS
011
018301
103CS1P
12"-MPS-011071302-103CS1P-H
SA-JER-DS011-TRJR-480044
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480044
4"
MPS
011
018301
103CS1P
SA-JER-DS011-TRJR-480204
011-C-0002
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480044
2"
MPS
011
018301
103CS1P
UC
4"-MPS-011018301-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480044
3/4"
MPS
011
018301
103CS1P
4"-MPS-011018301-103CS1P-H
Blind flange
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480139
8"
MPS
011
028002
103CS1P
011-D-0019
SA-JER-DS011-TRJR-480070
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480139
2"
MPS
011
028002
103CS1P
8"-MPS-011028002-103CS1P-H
Blind flange
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480139
6"
MPS
011
028002
103CS1P
8"-MPS-011028002-103CS1P-H
HEADER
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480139
3/4"
MPS
011
028002
103CS1P
HEADER
Plug
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
8"
MPS
011
028002
103CS1P
SA-JER-DS011-TRJR-480139
SA-JER-DS011-TRJR-480069
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
8"
MPS
011
028002
103CS1P
SA-JER-DS011-TRJR-480070
SA-JER-DS011-TRJR-480068
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
8"
MPS
011
028002
103CS1P
SA-JER-DS011-TRJR-480069
SA-JER-DS011-TRJR-480067
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
8"
MPS
011
028002
103CS1P
SA-JER-DS011-TRJR-480068
Reducer
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
3"
MPS
011
028002
103CS1P
Reducer
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
1/2"
MPS
011
028002
103CS1P
011-FE-0037
011-FT-0036-A
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
3/4"
MPS
011
028002
103CS1P
3"-MPS-011028002-103CS1P-H
Plug
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
1/2"
MPS
011
028002
103CS1P
011-FE-0037
011-FT-0037-A
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
1-1/2"
MPS
011
028002
103CS1P
Reducer
1-1/2"-MPS-011028002-103CS1PH
SA-JER-DS011-TRJR-480067
1/2"
MPS
011
028002
103CS1P
011-FE-0037
011-FT-0036-A
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
3"
MPS
011
028002
103CS1P
3"-MPS-011028002-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
1/2"
MPS
011
028002
103CS1P
011-FE-0037
011-FT-0037-A
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
1-1/2"
MPS
011
028002
103CS1P
Reducer
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
3"
MPS
011
028002
103CS1P
Reducer
3"-MPS-011028002-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
3"
MPS
011
028002
103CS1P
3"-MPS-011028002-103CS1P-H
3"-MPS-011028002-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
1-1/2"
MPS
011
028002
103CS1P
1-1/2"-MPS-011028002-103CS1PH
Reducer
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
3"
MPS
011
028002
103CS1P
Reducer
3"-MPS-011028002-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
3"
MPS
011
028002
103CS1P
3"-MPS-011028002-103CS1P-H
SA-JER-DS011-TRJR-480071
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
32.86
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480071
3"
MPS
011
028002
103CS1P
SA-JER-DS011-TRJR-480067
3"-MPS-011029001-103CM4P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
32.86
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
3"
MPS
011
028005
103CS1P
8"-MPS-011028002-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
3/4"
MPS
011
028005
103CS1P
3"-MPS-011028005-103CS1P-H
Plug
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
1/2"
MPS
011
028005
103CS1P
011-FE-0037
011-FT-0037-B
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
1/2"
MPS
011
028005
103CS1P
011-FE-0037
011-FT-0036-B
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
1/2"
MPS
011
028005
103CS1P
011-FE-0037
011-FT-0037-B
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
1-1/2"
MPS
011
028005
103CS1P
Reducer
1-1/2"-MPS-011028005-103CS1PH
SA-JER-DS011-TRJR-480067
3"
MPS
011
028005
103CS1P
3"-MPS-011028005-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
1/2"
MPS
011
028005
103CS1P
011-FE-0037
011-FT-0036-B
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
1-1/2"
MPS
011
028005
103CS1P
Reducer
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480072
3"
MPS
011
028005
103CS1P
SA-JER-DS011-TRJR-480067
3"-MPS-011029002-103CM4P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
32.86
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
3"
MPS
011
028005
103CS1P
Reducer
3"-MPS-011028005-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
3"
MPS
011
028005
103CS1P
3"-MPS-011028005-103CS1P-H
3"-MPS-011028005-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
3"
MPS
011
028005
103CS1P
Reducer
3"-MPS-011028005-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
Reducer
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480072
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
32.86
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
1-1/2"
MPS
011
028005
SA-JER-DS011-TRJR-480067
3"
MPS
011
028005
1-1/2"-MPS-011028005-103CS1P103CS1P H 103CS1P 3"-MPS-011028005-103CS1P-H
SA-JER-DS011-TRJR-480068
3"
MPS
011
028006
103CS1P
8"-MPS-011028002-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
1/2"
MPS
011
028006
103CS1P
011-FE-0037
011-FT-0036-C
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
1/2"
MPS
011
028006
103CS1P
011-FE-0037
011-FT-0037-C
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
1/2"
MPS
011
028006
103CS1P
011-FE-0037
011-FT-0037-C
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
1-1/2"
MPS
011
028006
103CS1P
Reducer
1-1/2"-MPS-011028006-103CS1PH
SA-JER-DS011-TRJR-480068
3/4"
MPS
011
028006
103CS1P
3"-MPS-011028006-103CS1P-H
Plug
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
1/2"
MPS
011
028006
103CS1P
011-FE-0037
011-FT-0036-C
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
Page 123 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
3"-MPS-011028006-103CS1P-H
TO
TYPE
INSULATION (NOTE 2)
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480068
3"
MPS
011
028006
103CS1P
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
1-1/2"
MPS
011
028006
103CS1P
Reducer
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480073
3"
MPS
011
028006
103CS1P
SA-JER-DS011-TRJR-480068
3"-MPS-011029003-103CM4P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
32.86
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
3"
MPS
011
028006
103CS1P
Reducer
3"-MPS-011028006-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
3"
MPS
011
028006
103CS1P
3"-MPS-011028006-103CS1P-H
3"-MPS-011028006-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
3"
MPS
011
028006
103CS1P
Reducer
3"-MPS-011028006-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
Reducer
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480073
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
32.86
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
1-1/2"
MPS
011
028006
SA-JER-DS011-TRJR-480068
3"
MPS
011
028006
1-1/2"-MPS-011028006-103CS1P103CS1P H 103CS1P 3"-MPS-011028006-103CS1P-H
SA-JER-DS011-TRJR-480069
3"
MPS
011
028007
103CS1P
8"-MPS-011028002-103CS1P-H
SA-JER-DS011-TRJR-480069
1/2"
MPS
011
028007
103CS1P
011-FE-0037
011-FT-0037-E
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
1-1/2"
MPS
011
028007
103CS1P
Reducer
1-1/2"-MPS-011028007-103CS1PH
SA-JER-DS011-TRJR-480069
1/2"
MPS
011
028007
103CS1P
011-FE-0037
011-FT-0037-E
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
3/4"
MPS
011
028007
103CS1P
3"-MPS-011028007-103CS1P-H
Plug
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
1/2"
MPS
011
028007
103CS1P
011-FE-0037
011-FT-0036-E
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
1/2"
MPS
011
028007
103CS1P
011-FE-0037
011-FT-0036-E
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
3"
MPS
011
028007
103CS1P
3"-MPS-011028007-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
1-1/2"
MPS
011
028007
103CS1P
Reducer
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480075
3"
MPS
011
028007
103CS1P
SA-JER-DS011-TRJR-480069
3"-MPS-011029005-103CM4P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
32.86
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
3"
MPS
011
028007
103CS1P
Reducer
3"-MPS-011028007-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
3"
MPS
011
028007
103CS1P
3"-MPS-011028007-103CS1P-H
3"-MPS-011028007-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
3"
MPS
011
028007
103CS1P
Reducer
3"-MPS-011028007-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
Reducer
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480075
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
32.86
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
1-1/2"
MPS
011
028007
SA-JER-DS011-TRJR-480069
3"
MPS
011
028007
1-1/2"-MPS-011028007-103CS1P103CS1P H 103CS1P 3"-MPS-011028007-103CS1P-H
SA-JER-DS011-TRJR-480070
3"
MPS
011
028008
103CS1P
8"-MPS-011028002-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
1/2"
MPS
011
028008
103CS1P
011-FE-0037
011-FT-0037-G
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
1/2"
MPS
011
028008
103CS1P
011-FE-0037
011-FT-0036-G
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
1/2"
MPS
011
028008
103CS1P
011-FE-0037
011-FT-0036-G
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
1/2"
MPS
011
028008
103CS1P
011-FE-0037
011-FT-0037-G
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
1-1/2"
MPS
011
028008
103CS1P
Reducer
1-1/2"-MPS-011028008-103CS1PH
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
3/4"
MPS
011
028008
103CS1P
3"-MPS-011028008-103CS1P-H
Plug
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
3"
MPS
011
028008
103CS1P
3"-MPS-011028008-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
1-1/2"
MPS
011
028008
103CS1P
Reducer
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480077
3"
MPS
011
028008
103CS1P
SA-JER-DS011-TRJR-480070
3"-MPS-011029007-103CM4P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
32.86
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
3"
MPS
011
028008
103CS1P
Reducer
3"-MPS-011028008-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
3"
MPS
011
028008
103CS1P
3"-MPS-011028008-103CS1P-H
3"-MPS-011028008-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480077
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
32.86
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
1-1/2"
MPS
011
028008
SA-JER-DS011-TRJR-480070
3"
MPS
011
028008
1-1/2"-MPS-011028008-103CS1P103CS1P Reducer H 103CS1P Reducer 3"-MPS-011028008-103CS1P-H
SA-JER-DS011-TRJR-480070
3"
MPS
011
028008
103CS1P
3"-MPS-011028008-103CS1P-H
SA-JER-DS011-TRJR-480068
3"
MPS
011
028009
103CS1P
8"-MPS-011028002-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
1-1/2"
MPS
011
028009
103CS1P
Reducer
1-1/2"-MPS-011028009-103CS1PH
SA-JER-DS011-TRJR-480068
3"
MPS
011
028009
103CS1P
3"-MPS-011028009-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
1/2"
MPS
011
028009
103CS1P
011-FE-0037
011-FT-0037-D
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
3/4"
MPS
011
028009
103CS1P
3"-MPS-011028009-103CS1P-H
Plug
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
1/2"
MPS
011
028009
103CS1P
011-FE-0037
011-FT-0036-D
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
1/2"
MPS
011
028009
103CS1P
011-FE-0037
011-FT-0036-D
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
1/2"
MPS
011
028009
103CS1P
011-FE-0037
011-FT-0037-D
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
1-1/2"
MPS
011
028009
103CS1P
Reducer
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480074
3"
MPS
011
028009
103CS1P
SA-JER-DS011-TRJR-480068
3"-MPS-011029004-103CM4P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
32.86
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
3"
MPS
011
028009
103CS1P
Reducer
3"-MPS-011028009-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
3"
MPS
011
028009
103CS1P
3"-MPS-011028009-103CS1P-H
3"-MPS-011028009-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
32.86
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
1-1/2"
MPS
011
028009
SA-JER-DS011-TRJR-480068
3"
MPS
011
028009
1-1/2"-MPS-011028009-103CS1P103CS1P Reducer H 103CS1P Reducer 3"-MPS-011028009-103CS1P-H
SA-JER-DS011-TRJR-480068
3"
MPS
011
028009
103CS1P
3"-MPS-011028009-103CS1P-H
SA-JER-DS011-TRJR-480074
SA-JER-DS011-TRJR-480069
3"
MPS
011
028010
103CS1P
8"-MPS-011028002-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
1/2"
MPS
011
028010
103CS1P
011-FE-0037
011-FT-0037-F
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
1-1/2"
MPS
011
028010
103CS1P
Reducer
1-1/2"-MPS-011028010-103CS1PH
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
3/4"
MPS
011
028010
103CS1P
3"-MPS-011028010-103CS1P-H
Plug
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
3"
MPS
011
028010
103CS1P
3"-MPS-011028010-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
1/2"
MPS
011
028010
103CS1P
011-FE-0037
011-FT-0037-F
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
1/2"
MPS
011
028010
103CS1P
011-FE-0037
011-FT-0036-F
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
1/2"
MPS
011
028010
103CS1P
011-FE-0037
011-FT-0036-F
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
1-1/2"
MPS
011
028010
103CS1P
Reducer
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480076
3"
MPS
011
028010
103CS1P
SA-JER-DS011-TRJR-480069
3"-MPS-011029006-103CM4P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
32.86
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
3"
MPS
011
028010
103CS1P
Reducer
3"-MPS-011028010-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
3"
MPS
011
028010
103CS1P
3"-MPS-011028010-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
3"-MPS-011028010-103CS1P-H
SA-JER-DS011-TRJR-480069
1-1/2"
MPS
011
028010
SA-JER-DS011-TRJR-480069
3"
MPS
011
028010
1-1/2"-MPS-011028010-103CS1P103CS1P Reducer H 103CS1P Reducer 3"-MPS-011028010-103CS1P-H
SA-JER-DS011-TRJR-480069
3"
MPS
011
028010
103CS1P
3"-MPS-011028010-103CS1P-H
SA-JER-DS011-TRJR-480076
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
32.86
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
3"
MPS
011
028011
103CS1P
8"-MPS-011028002-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
1/2"
MPS
011
028011
103CS1P
011-FE-0037
011-FT-0037-H
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
1/2"
MPS
011
028011
103CS1P
011-FE-0037
011-FT-0036-H
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
1/2"
MPS
011
028011
103CS1P
011-FE-0037
011-FT-0037-H
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
1/2"
MPS
011
028011
103CS1P
011-FE-0037
011-FT-0036-H
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
1-1/2"
MPS
011
028011
103CS1P
Reducer
1-1/2"-MPS-011028011-103CS1PH
SA-JER-DS011-TRJR-480070
3/4"
MPS
011
028011
103CS1P
3"-MPS-011028011-103CS1P-H
Plug
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
3"
MPS
011
028011
103CS1P
3"-MPS-011028011-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
1-1/2"
MPS
011
028011
103CS1P
Reducer
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480078
3"
MPS
011
028011
103CS1P
SA-JER-DS011-TRJR-480070
3"-MPS-011029008-103CM4P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
32.86
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
3"
MPS
011
028011
103CS1P
Reducer
3"-MPS-011028011-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
3"
MPS
011
028011
103CS1P
3"-MPS-011028011-103CS1P-H
3"-MPS-011028011-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
1-1/2"
MPS
011
028011
103CS1P
1-1/2"-MPS-011028011-103CS1PH
Reducer
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
3"
MPS
011
028011
103CS1P
Reducer
3"-MPS-011028011-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
3"
MPS
011
028011
103CS1P
3"-MPS-011028011-103CS1P-H
SA-JER-DS011-TRJR-480078
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
32.86
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480204
10"
MPS
011
028301
103CS1P
12"-MPS-011071302-103CS1P-H
SA-JER-DS011-TRJR-480139
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480139
10"
MPS
011
028301
103CS1P
SA-JER-DS011-TRJR-480204
SA-JER-DS011-TRJR-480070
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480139
8"
MPS
011
028301
103CS1P
10"-MPS-011028301-103CS1P-H
HEADER
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480139
3/4"
MPS
011
028301
103CS1P
HEADER
Plug
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
10"
MPS
011
028301
103CS1P
SA-JER-DS011-TRJR-480139
SA-JER-DS011-TRJR-480069
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
Page 124 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480069
10"
MPS
011
028301
103CS1P
SA-JER-DS011-TRJR-480070
SA-JER-DS011-TRJR-480068
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
10"
MPS
011
028301
103CS1P
SA-JER-DS011-TRJR-480069
SA-JER-DS011-TRJR-480067
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
10"
MPS
011
028301
103CS1P
SA-JER-DS011-TRJR-480068
Cap
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
10"
MPS
011
028301
103CS1P
10"-MPS-011028301-103CS1P-H
6"-HFO-011028109-103CL4P-S
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480204
8"
MPS
011
028302
103CS1P
12"-MPS-011071302-103CS1P-H
SA-JER-DS011-TRJR-480139
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480139
8"
MPS
011
028302
103CS1P
SA-JER-DS011-TRJR-480204
011-D-0019
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480067
6"
MPS
011
028303
103CS1P
10"-MPS-011028301-103CS1P-H
6"-HFO-011027113-103CL4P-S
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
6"
MPS
011
028306
103CS1P
10"-MPS-011028301-103CS1P-H
6"-HFO-011027115-103CL4P-S
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480068
6"
MPS
011
028308
103CS1P
10"-MPS-011028301-103CS1P-H
6"-HFO-011027116-103CL4P-S
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
6"
MPS
011
028310
103CS1P
10"-MPS-011028301-103CS1P-H
6"-HFO-011027117-103CL4P-S
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480069
6"
MPS
011
028312
103CS1P
10"-MPS-011028301-103CS1P-H
6"-HFO-011027118-103CL4P-S
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
6"
MPS
011
028314
103CS1P
10"-MPS-011028301-103CS1P-H
6"-HFO-011027119-103CL4P-S
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480070
6"
MPS
011
028316
103CS1P
10"-MPS-011028301-103CS1P-H
6"-HFO-011027120-103CL4P-S
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
if insulated N or Q SA-JER-DS011-TRJR-480139
-
MPS
011
028601
103CS1P
011-D-0019
TRIM
-
-
H
-
-
-
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
Visual Test
0.00
NFS
By Code
SA-JER-DS011-TRJR-480139
2"
MPS
011
028601
103CS1P
011-D-0019
Blind flange
-
-
H
65
-
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
SA-JER-DS011-TRJR-480139
2"
MPS
011
028601
103CS1P
011-D-0019
Blind flange
-
-
H
65
-
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
SA-JER-DS011-TRJR-480071
3"
MPS
011
029001
103CM4P
3"-MPS-011028002-103CS1P-H
3"-MPS-011029001-103CM4P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
YES
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480071
3"
MPS
011
029001
103CM4P
3"-MPS-011029001-103CM4P-H
011-F-0002
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480071
3"
MPS
011
029001
103CM4P
3"-MPS-011029001-103CM4P-H
011-F-0002
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480072
3"
MPS
011
029002
103CM4P
3"-MPS-011028005-103CS1P-H
3"-MPS-011029002-103CM4P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
YES
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480072
3"
MPS
011
029002
103CM4P
3"-MPS-011029002-103CM4P-H
011-F-0002
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480072
3"
MPS
011
029002
103CM4P
3"-MPS-011029002-103CM4P-H
011-F-0002
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480073
3"
MPS
011
029003
103CM4P
3"-MPS-011028006-103CS1P-H
3"-MPS-011029003-103CM4P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
YES
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480073
3"
MPS
011
029003
103CM4P
3"-MPS-011029003-103CM4P-H
011-F-0002
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
YES
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480073
3"
MPS
011
029003
103CM4P
3"-MPS-011029003-103CM4P-H
011-F-0002
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
YES
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480074
3"
MPS
011
029004
103CM4P
3"-MPS-011028009-103CS1P-H
3"-MPS-011029004-103CM4P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
YES
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480074
3"
MPS
011
029004
103CM4P
3"-MPS-011029004-103CM4P-H
011-F-0002
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
YES
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480074
3"
MPS
011
029004
103CM4P
3"-MPS-011029004-103CM4P-H
011-F-0002
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
YES
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480075
3"
MPS
011
029005
103CM4P
3"-MPS-011028007-103CS1P-H
3"-MPS-011029005-103CM4P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
YES
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480075
3"
MPS
011
029005
103CM4P
3"-MPS-011029005-103CM4P-H
011-F-0002
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
YES
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480075
3"
MPS
011
029005
103CM4P
3"-MPS-011029005-103CM4P-H
011-F-0002
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
YES
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480076
3"
MPS
011
029006
103CM4P
3"-MPS-011028010-103CS1P-H
3"-MPS-011029006-103CM4P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
YES
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480076
3"
MPS
011
029006
103CM4P
3"-MPS-011029006-103CM4P-H
011-F-0002
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
YES
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480076
3"
MPS
011
029006
103CM4P
3"-MPS-011029006-103CM4P-H
011-F-0002
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
YES
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480077
3"
MPS
011
029007
103CM4P
3"-MPS-011028008-103CS1P-H
3"-MPS-011029007-103CM4P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
YES
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480077
3"
MPS
011
029007
103CM4P
3"-MPS-011029007-103CM4P-H
011-F-0002
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
YES
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480077
3"
MPS
011
029007
103CM4P
3"-MPS-011029007-103CM4P-H
011-F-0002
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
YES
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480078
3"
MPS
011
029008
103CM4P
3"-MPS-011028011-103CS1P-H
3"-MPS-011029008-103CM4P-H
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
YES
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480078
3"
MPS
011
029008
103CM4P
3"-MPS-011029008-103CM4P-H
011-F-0002
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
YES
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480078
3"
MPS
011
029008
103CM4P
3"-MPS-011029008-103CM4P-H
011-F-0002
-
-
H
65
MP STEAM
Gas
-
8.10
270.00
-
-
12.00
-1.00
425.00
425.00
-
H
28.06
NFS
YES
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480204
4"
MPS
011
030301
103CS1P
12"-MPS-011071302-103CS1P-H
SA-JER-DS011-TRJR-480081
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480081
4"
MPS
011
030301
103CS1P
SA-JER-DS011-TRJR-480204
011-C-0003
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480081
3/4"
MPS
011
030301
103CS1P
4"-MPS-011030301-103CS1P-H
Blind flange
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480081
2"
MPS
011
030301
103CS1P
UC
4"-MPS-011030301-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
8"
MPS
011
032001
103CS1P
011-D-0024
8"-MPS-011032001-103CS1P-H
-
-
H
100
MP STEAM
Gas
-
14.30
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
2"
MPS
011
032001
103CS1P
8"-MPS-011032001-103CS1P-H
011-TT-0155
-
-
H
65
MP STEAM
Gas
-
14.30
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
3/4"
MPS
011
032001
103CS1P
8"-MPS-011032001-103CS1P-H
011-PT-0076
-
-
H
65
MP STEAM
Gas
-
14.30
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q
-
SA-JER-DS011-TRJR-480084
6"
MPS
011
032001
103CS1P
Reducer
6"-MPS-011032001-103CS1P-H
-
-
H
100
MP STEAM
Gas
-
14.30
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
3/4"
MPS
011
032001
103CS1P
8"-MPS-011032001-103CS1P-H
Plug
-
-
H
65
MP STEAM
Gas
-
14.30
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
8"
MPS
011
032001
103CS1P
8"-MPS-011032001-103CS1P-H
Reducer
-
-
H
100
MP STEAM
Gas
-
14.30
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
8"
MPS
011
032001
103CS1P
8"-MPS-011032001-103CS1P-H
HEADER
-
-
H
100
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
6"
MPS
011
032001
103CS1P
6"-MPS-011032001-103CS1P-H
Reducer
-
-
H
100
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
3/4"
MPS
011
032001
103CS1P
8"-MPS-011032001-103CS1P-H
011-PT-0381
-
-
H
65
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
1/2"
MPS
011
032001
103CS1P
011-FE-0151
011-FT-0151
-
-
H
40
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
Reducer
8"-MPS-011032001-103CS1P-H
-
-
H
100
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
-
H
40
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
8"
MPS
011
032001
103CS1P
SA-JER-DS011-TRJR-480084
1/2"
MPS
011
032001
103CS1P
011-FE-0151
011-FT-0151
-
MP STEAM
Gas
SA-JER-DS011-TRJR-480084
8"
MPS
011
032002
103CS1P
8"-MPS-011032001-103CS1P-H
8"-MPS-011032002-103CS1P-H
-
-
H
100
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
8"
MPS
011
032002
103CS1P
HEADER
HEADER
-
-
H
100
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
4"
MPS
011
032003
103CS1P
8"-MPS-011032001-103CS1P-H
4"-MPS-011032003-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
4"
MPS
011
032003
103CS1P
HEADER
HEADER
-
-
H
65
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
6"
MPS
011
032004
103CS1P
8"-MPS-011032001-103CS1P-H
6"-MPS-011032004-103CS1P-H
-
-
H
100
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
6"
MPS
011
032004
103CS1P
HEADER
HEADER
-
-
H
100
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
3"
MPS
011
032005
103CS1P
8"-MPS-011032002-103CS1P-H
011-J-0001-B
-
-
H
65
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
3"
MPS
011
032006
103CS1P
8"-MPS-011032002-103CS1P-H
011-J-0001-C
-
-
H
65
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
2"
MPS
011
032007
103CS1P
4"-MPS-011032003-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
1-1/2"
MPS
011
032007
103CS1P
Reducer
011-J-0002-B
-
-
H
65
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
2"
MPS
011
032008
103CS1P
4"-MPS-011032003-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
1-1/2"
MPS
011
032008
103CS1P
Reducer
011-J-0002-C
-
-
H
65
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
3"
MPS
011
032009
103CS1P
6"-MPS-011032004-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
1-1/2"
MPS
011
032009
103CS1P
Reducer
011-J-0003-B
-
-
H
65
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
3"
MPS
011
032010
103CS1P
6"-MPS-011032004-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
1-1/2"
MPS
011
032010
103CS1P
Reducer
011-J-0003-C
-
-
H
65
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
3"
MPS
011
032011
103CS1P
8"-MPS-011032002-103CS1P-H
011-J-0001-A
-
-
H
65
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
2"
MPS
011
032012
103CS1P
4"-MPS-011032003-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
1-1/2"
MPS
011
032012
103CS1P
Reducer
011-J-0002-A
-
-
H
65
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
3"
MPS
011
032013
103CS1P
6"-MPS-011032004-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
1-1/2"
MPS
011
032013
103CS1P
Reducer
011-J-0003-A
-
-
H
65
MP STEAM
Gas
-
13.80
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480203
8"
MPS
011
032301
103CS1P
12"-MPS-011071302-103CS1P-H
SA-JER-DS011-TRJR-480084
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
8"
MPS
011
032301
103CS1P
SA-JER-DS011-TRJR-480203
011-D-0024
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480084
2"
MPS
011
032302
103CS1P
011-D-0024
Reducer
-
-
H
65
MP STEAM
Liquid/Gas Mixture
866.6
14.00
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480084
2"
MPS
011
032302
103CS1P
2"-MPS-011032302-103CS1P-H
011-LG-0116
-
-
H
65
MP STEAM
Liquid/Gas Mixture
866.6
14.00
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480084
3/4"
MPS
011
032302
103CS1P
011-LG-0116
Blind flange
-
-
H
65
MP STEAM
Liquid/Gas Mixture
866.6
14.00
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480084
2"
MPS
011
032302
103CS1P
2"-MPS-011032302-103CS1P-H
011-LT-0117
-
-
H
65
MP STEAM
Liquid/Gas Mixture
866.6
14.00
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-380001
Page 125 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
INSULATION (NOTE 2)
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480084
3/4"
MPS
011
032302
103CS1P
Reducer
3/4"-MPC-011032301-103CS1P-H
-
-
H
65
MP STEAM
Liquid/Gas Mixture
866.6
14.00
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480084
3/4"
MPS
011
032302
103CS1P
2"-MPS-011032302-103CS1P-H
Plug
-
-
H
65
MP STEAM
Liquid/Gas Mixture
866.6
14.00
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480084
2"
MPS
011
032302
103CS1P
2"-MPS-011032302-103CS1P-H
011-LG-0116
-
-
H
65
MP STEAM
Liquid/Gas Mixture
866.6
14.00
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480084
3/4"
MPS
011
032302
103CS1P
2"-MPS-011032302-103CS1P-H
Plug
-
-
H
65
MP STEAM
Liquid/Gas Mixture
866.6
14.00
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480084
3/4"
MPS
011
032302
103CS1P
011-LG-0116
Blind flange
-
-
H
65
MP STEAM
Liquid/Gas Mixture
866.6
14.00
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480084
2"
MPS
011
032302
103CS1P
2"-MPS-011032302-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Liquid/Gas Mixture
866.6
14.00
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480084
2"
MPS
011
032302
103CS1P
2"-MPS-011032302-103CS1P-H
011-LT-0117
-
-
H
65
MP STEAM
Liquid/Gas Mixture
866.6
14.00
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480084
1"
MPS
011
032302
103CS1P
Reducer
Reducer
-
-
H
65
MP STEAM
Liquid/Gas Mixture
866.6
14.00
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480084
2"
MPS
011
032302
103CS1P
Reducer
2"-MPC-011032301-103CS1P-H
-
-
H
65
MP STEAM
Liquid/Gas Mixture
866.6
14.00
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480084
3/4"
MPS
011
032302
103CS1P
2"-MPS-011032302-103CS1P-H
Plug
-
-
H
65
MP STEAM
Liquid/Gas Mixture
866.6
14.00
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480202
12"
MPS
011
071301
103CS1P
IP-1328-L
011-DS-0003
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
MAX. OPERATING TEMPERATURE COULD BE :320
NOTE 7
SA-JER-DS011-TRJR-480202
2"
MPS
011
071301
103CS1P
12"-MPS-011071301-103CS1P-H
011-TT-0246
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
MAX. OPERATING TEMPERATURE COULD BE :320
SA-JER-DS011-TRJR-480202
3/4"
MPS
011
071301
103CS1P
12"-MPS-011071301-103CS1P-H
Plug
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
MAX. OPERATING TEMPERATURE COULD BE :320
SA-JER-DS011-TRJR-480202
1/2"
MPS
011
071301
103CS1P
011-FE-0092
011-FT-0094
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
MAX. OPERATING TEMPERATURE COULD BE :320
SA-JER-DS011-TRJR-480202
1/2"
MPS
011
071301
103CS1P
011-FE-0092
011-FT-0094
-
-
H
40
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
MAX. OPERATING TEMPERATURE COULD BE :320
SA-JER-DS011-TRJR-480202
3/4"
MPS
011
071301
103CS1P
12"-MPS-011071301-103CS1P-H
011-FT-0094
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
MAX. OPERATING TEMPERATURE COULD BE :320
SA-JER-DS011-TRJR-480202
3/4"
MPS
011
071301
103CS1P
12"-MPS-011071301-103CS1P-H
011-PT-0265
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
MAX. OPERATING TEMPERATURE COULD BE :320
SA-JER-DS011-TRJR-480202
12"
MPS
011
071302
103CS1P
011-DS-0003
SA-JER-DS011-TRJR-480206
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
2"
MPS
011
071302
103CS1P
12"-MPS-011071302-103CS1P-H
011-TT-0233
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
12"
MPS
011
071302
103CS1P
12"-MPS-011071302-103CS1P-H
SA-JER-DS011-TRJR-480204
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480206
12"
MPS
011
071302
103CS1P
SA-JER-DS011-TRJR-480202
HEADER
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480204
12"
MPS
011
071302
103CS1P
SA-JER-DS011-TRJR-480202
SA-JER-DS011-TRJR-480313
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480313
12"
MPS
011
071302
103CS1P
SA-JER-DS011-TRJR-480204
SA-JER-DS011-TRJR-480205
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480205
12"
MPS
011
071302
103CS1P
SA-JER-DS011-TRJR-480313
SA-JER-DS011-TRJR-480203
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480203
12"
MPS
011
071302
103CS1P
SA-JER-DS011-TRJR-480205
HEADER
-
-
H
100
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480206
1-1/2"
MPS
011
071701
103CS1P
12"-MPS-011071302-103CS1P-H
011-SM-0001-MS
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480206
1-1/2"
MPS
011
071702
103CS1P
2"-MPS-011071704-103CS1P-H
011-SM-002-MS
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480206
1-1/2"
MPS
011
071703
103CS1P
2"-MPS-011071704-103CS1P-H
011-SM-003-MS
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480206
2"
MPS
011
071704
103CS1P
12"-MPS-011071302-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480206
1-1/2"
MPS
011
071704
103CS1P
Reducer
011-SM-004-MS
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
1-1/2"
MPS
011
071705
103CS1P
12"-MPS-011071302-103CS1P-H
011-SM-005-MS
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
1-1/2"
MPS
011
071706
103CS1P
12"-MPS-011071301-103CS1P-H
011-SM-006-MS
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480204
1-1/2"
MPS
011
071707
103CS1P
011-SM-007-MS
12"-MPS-011071302-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480204
1-1/2"
MPS
011
071708
103CS1P
011-SM-008-MS
12"-MPS-011071302-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480204
1-1/2"
MPS
011
071709
103CS1P
011-SM-009-MS
12"-MPS-011071302-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480204
1-1/2"
MPS
011
071710
103CS1P
011-SM-010-MS
12"-MPS-011071302-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480204
1-1/2"
MPS
011
071711
103CS1P
2"-MPS-011071712-103CS1P-H
011-SM-011-MS
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480204
2"
MPS
011
071712
103CS1P
12"-MPS-011071302-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480204
1-1/2"
MPS
011
071712
103CS1P
Reducer
011-SM-012-MS
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480204
1-1/2"
MPS
011
071713
103CS1P
011-SM-013-MS
12"-MPS-011071302-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480203
2"
MPS
011
071714
103CS1P
12"-MPS-011071302-103CS1P-H
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480203
1-1/2"
MPS
011
071714
103CS1P
Reducer
011-SM-014-MS
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480203
1-1/2"
MPS
011
071715
103CS1P
2"-MPS-011071714-103CS1P-H
011-SM-015-MS
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480202
1-1/2"
MPS
011
071716
103CS1P
12"-MPS-011071301-103CS1P-H
011-SM-016-MS
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
3"
MPS
011
076301
103CS1P
12"-MPS-011071301-103CS1P-H
SA-JER-DS011-TRJR-480219
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
MAX. OPERATING TEMPERATURE COULD BE :320
SA-JER-DS011-TRJR-480219
3"
MPS
011
076301
103CS1P
SA-JER-DS011-TRJR-480202
3"-SLP-011076012-103CH2S-H
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480206
1"
MPS
011
230301
103CS1P
12"-MPS-011071302-103CS1P-H
SA-JER-DS011-TRJR-480290
-
-
H
65
LP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
290.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
NOTE 7.
350.00
-
SA-JER-DS011-TRJR-480290
1"
MPS
011
230301
103CS1P
SA-JER-DS011-TRJR-480206
011-AS-0002
-
-
H
65
MEDIUM PRESSURE STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480290
3/4"
MPS
011
230301
103CS1P
1"-MPS-011230301-103CS1P-H
Plug
-
-
H
65
MEDIUM PRESSURE STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480290
1"
MPS
011
230302
103CS1P
011-AS-0002
Reducer
-
-
H
65
MEDIUM PRESSURE STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480290
1"
MPS
011
230302
103CS1P
Reducer
1"-MPS-011230302-103CS1P-H
-
-
H
65
MEDIUM PRESSURE STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480290
3/4"
MPS
011
230302
103CS1P
3/4"-MPC-011230301-103CS1PH
Reducer
-
-
H
65
MEDIUM PRESSURE STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480290
3/4"
MPS
011
230302
103CS1P
1"-MPS-011230302-103CS1P-H
Plug
-
-
H
65
MEDIUM PRESSURE STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480290
3/4"
MPS
011
230302
103CS1P
1"-MPS-011230302-103CS1P-H
Plug
-
-
H
65
MEDIUM PRESSURE STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480290
3/4"
MPS
011
230302
103CS1P
1"-MPS-011230302-103CS1P-H
Plug
-
-
H
65
MEDIUM PRESSURE STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.00
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480290
3/4"
MPS
011
230302
103CS1P
Reducer
Reducer
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480290
1"
MPS
011
230302
103CS1P
Reducer
1"-MPC-011230301-103CS1P-H
-
-
H
65
MP STEAM
Gas
-
16.50
270.00
-
-
19.00
-1.00
350.00
350.0
-
H
33.77
NFS
By Code
N or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480213
4"
N2L
011
018301
101CS1P
4"-N2L-011074302-101CS1P-N
SA-JER-DS011-TRJR-480043
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480043
4"
N2L
011
018301
101CS1P
SA-JER-DS011-TRJR-480213
4"-NAP-011018005-101CH2S-N
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480213
2"
N2L
011
035301
101CS1P
4"-N2L-011074302-101CS1P-N
SA-JER-DS011-TRJR-480264
-
-
N
-
INSTRUMENT AIR
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480264
2"
N2L
011
035301
101CS1P
SA-JER-DS011-TRJR-480213
Reducer
-
-
N
-
INSTRUMENT AIR
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480264
1"
N2L
011
035301
101CS1P
Reducer
TP-16
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480213
2"
N2L
011
035302
101CS1P
2"-N2L-011035301-101CS1P-N
SA-JER-DS011-TRJR-480091
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
-1.00
80.00
100.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480091
2"
N2L
011
035302
101CS1P
SA-JER-DS011-TRJR-480213
2"-GAS-011034014-101CH4S-N
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
-1.00
80.00
100.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480264
1"
N2L
011
035303
101CS1P
TP-16
011-K-0001
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480264
1"
N2L
011
035303
101CS1P
1"-N2L-011035303-101CS1P-N
011-K-0001
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480211
2"
N2L
011
043301
101CS1P
4"-N2L-011074301-101CS1P-N
SA-JER-DS011-TRJR-480112
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
2"
N2L
011
043301
101CS1P
SA-JER-DS011-TRJR-480211
2"-N2L-011043301-101CS1P-N
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
2"
N2L
011
043301
101CS1P
2"-N2L-011043301-101CS1P-N
2"-PRW-011043001-101CS1P-N
-
-
N
-
NITROGEN
Gas
-
1.00
50.00
-
-
3.50
150.00
-
PNEU
3.85
D
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480211
4"
N2L
011
074301
101CS1P
IP-1321-L
SA-JER-DS011-TRJR-480212
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480212
4"
N2L
011
074301
101CS1P
SA-JER-DS011-TRJR-480211
HEADER
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX TEMPERATURE
SA-JER-DS011-TRJR-480212
4"
N2L
011
074302
101CS1P
SA-JER-DS011-TRJR-480213
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX TEMPERATURE
SA-JER-DS011-TRJR-480213
4"
N2L
011
074302
101CS1P
SA-JER-DS011-TRJR-480212
HEADER
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX TEMPERATURE
SA-JER-DS011-TRJR-480306
1"
N2L
011
074303
101CS1P
4"-N2L-011074302-101CS1P-N
011-US-001
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
2"
N2L
011
074306
101CS1P
4"-N2L-011074302-101CS1P-N
Reducer
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
N2L
011
074306
101CS1P
Reducer
011-US-018
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
N2L
011
074307
101CS1P
2"-N2L-011074306-101CS1P-N
011-US-021
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
N2L
011
074308
101CS1P
4"-N2L-011074302-101CS1P-N
011-US-022
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
2"
N2L
011
074309
101CS1P
4"-N2L-011074302-101CS1P-N
Reducer
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
N2L
011
074309
101CS1P
Reducer
011-US-093
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
2"
N2L
011
074313
101CS1P
4"-N2L-011074302-101CS1P-N
Reducer
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
N2L
011
074313
101CS1P
Reducer
011-US-096
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
N2L
011
074314
101CS1P
2"-N2L-011074316-101CS1P-N
011-US-107
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
2"
N2L
011
074316
101CS1P
2"-N2L-011074302-101CS1P-N
Reducer
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
N2L
011
074316
101CS1P
Reducer
011-US-108
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
N2L
011
074320
101CS1P
4"-N2L-011074302-101CS1P-N
011-US-032
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
N2L
011
074321
101CS1P
4"-N2L-011074302-101CS1P-N
011-US-031
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
2"
N2L
011
074322
101CS1P
4"-N2L-011074302-101CS1P-N
Reducer
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
N2L
011
074322
101CS1P
Reducer
011-US-033
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
4"-N2L-011074301-101CS1P-N
-
Page 126 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480306
1"
N2L
011
074323
101CS1P
2"-N2L-011074322-101CS1P-N
011-US-034
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
N2L
011
074324
101CS1P
4"-N2L-011074302-101CS1P-N
011-US-029
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
N2L
011
074325
101CS1P
4"-N2L-011074302-101CS1P-N
011-US-035
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
N2L
011
074326
101CS1P
4"-N2L-011074302-101CS1P-N
011-US-036
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
N2L
011
074327
101CS1P
4"-N2L-011074302-101CS1P-N
011-US-011
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
N2L
011
074328
101CS1P
4"-N2L-011074302-101CS1P-N
011-US-037
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
N2L
011
074329
101CS1P
2"-N2L-011074331-101CS1P-N
011-US-043
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
2"
N2L
011
074330
101CS1P
4"-N2L-011074302-101CS1P-N
Reducer
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
N2L
011
074330
101CS1P
Reducer
011-US-050
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
2"
N2L
011
074331
101CS1P
2"-N2L-011074330-101CS1P-N
Reducer
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
N2L
011
074331
101CS1P
Reducer
011-US-044
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
N2L
011
074332
101CS1P
2"-N2L-011074330-101CS1P-N
011-US-042
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
N2L
011
074333
101CS1P
4"-N2L-011074302-101CS1P-N
011-US-019
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
N2L
011
074334
101CS1P
4"-N2L-011074302-101CS1P-N
011-US-020
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
N2L
011
074335
101CS1P
4"-N2L-011074302-101CS1P-N
011-US-064
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
N2L
011
074336
101CS1P
4"-N2L-011074302-101CS1P-N
011-US-062
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
N2L
011
074337
101CS1P
4"-N2L-011074302-101CS1P-N
011-US-059
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
N2L
011
074338
101CS1P
4"-N2L-011074302-101CS1P-N
011-US-056
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
2"
N2L
011
074339
101CS1P
4"-N2L-011074302-101CS1P-N
Reducer
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
N2L
011
074339
101CS1P
Reducer
011-US-038
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
N2L
011
074340
101CS1P
2"-N2L-011074339-101CS1P-N
011-US-057
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
N2L
011
074341
101CS1P
2"-N2L-011074344-101CS1P-N
1"-N2L-011074341-101CS1P-N
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
N2L
011
074341
101CS1P
1"-N2L-011074341-101CS1P-N
011-US-060
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
N2L
011
074342
101CS1P
2"-N2L-011074344-101CS1P-N
011-US-075
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
N2L
011
074343
101CS1P
2"-N2L-011074344-101CS1P-N
011-US-076
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
2"
N2L
011
074344
101CS1P
4"-N2L-011074302-101CS1P-N
Reducer
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
N2L
011
074344
101CS1P
Reducer
011-US-077
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
N2L
011
074345
101CS1P
2"-N2L-011074347-101CS1P-N
011-US-074
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
N2L
011
074346
101CS1P
2"-N2L-011074347-101CS1P-N
011-US-079
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
2"
N2L
011
074347
101CS1P
4"-N2L-011074302-101CS1P-N
Reducer
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
N2L
011
074347
101CS1P
Reducer
011-US-078
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
N2L
011
074348
101CS1P
2"-N2L-011074347-101CS1P-N
011-US-080
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
2"
N2L
011
074349
101CS1P
2"-N2L-011074347-101CS1P-N
Reducer
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
N2L
011
074349
101CS1P
Reducer
011-US-082
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
N2L
011
074350
101CS1P
2"-N2L-011074349-101CS1P-N
011-US-084
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
N2L
011
074351
101CS1P
4"-N2L-011074302-101CS1P-N
011-US-121
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
N2L
011
074352
101CS1P
4"-N2L-011074302-101CS1P-N
011-US-067
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
N2L
011
074353
101CS1P
2"-N2L-011074354-101CS1P-N
011-US-122
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
2"
N2L
011
074354
101CS1P
4"-N2L-011074302-101CS1P-N
Reducer
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
N2L
011
074354
101CS1P
Reducer
011-US-124
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
N2L
011
074355
101CS1P
2"-N2L-011074354-101CS1P-N
011-US-123
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
N2L
011
074356
101CS1P
4"-N2L-011074302-101CS1P-N
011-US-065
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
N2L
011
074357
101CS1P
1"-N2L-011074373-101CS1P-N
011-US-129
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
N2L
011
074358
101CS1P
2"-N2L-011074363-101CS1P-N
011-US-097
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
N2L
011
074359
101CS1P
2"-N2L-011074363-101CS1P-N
011-US-101
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
N2L
011
074360
101CS1P
2"-N2L-011074309-101CS1P-N
011-US-089
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
N2L
011
074361
101CS1P
2"-N2L-011074309-101CS1P-N
011-US-091
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
N2L
011
074362
101CS1P
4"-N2L-011074302-101CS1P-N
011-US-063
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
2"
N2L
011
074363
101CS1P
2"-N2L-011074313-101CS1P-N
Reducer
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
N2L
011
074363
101CS1P
Reducer
011-US-105
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
N2L
011
074364
101CS1P
2"-N2L-011074316-101CS1P-N
011-US-116
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
1"
N2L
011
074365
101CS1P
2"-N2L-011074302-101CS1P-N
011-US-130
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
1"
N2L
011
074366
101CS1P
1"-N2L-011074368-101CS1P-N
011-US-118
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
N2L
011
074367
101CS1P
1"-N2L-011074368-101CS1P-N
011-US-120
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
1"
N2L
011
074368
101CS1P
2"-N2L-011074302-101CS1P-N
SA-JER-DS011-TRJR-480315
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
N2L
011
074368
101CS1P
SA-JER-DS011-TRJR-480310
Reducer
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
N2L
011
074368
101CS1P
Reducer
011-US-131
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
N2L
011
074369
101CS1P
1"-N2L-011074368-101CS1P-N
011-US-119
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
N2L
011
074370
101CS1P
2"-N2L-011074302-101CS1P-N
011-US-117
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
N2L
011
074371
101CS1P
2"-N2L-011074302-101CS1P-N
011-US-113
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
N2L
011
074372
101CS1P
4"-N2L-011074302-101CS1P-N
011-US-023
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
N2L
011
074373
101CS1P
1"-N2L-011074368-101CS1P-N
Reducer
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
3/4"
N2L
011
074373
101CS1P
Reducer
011-US-132
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480212
2"
N2L
011
076301
101CS1P
4"-N2L-011074301-101CS1P-N
SA-JER-DS011-TRJR-480218
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480218
2"
N2L
011
076301
101CS1P
SA-JER-DS011-TRJR-480212
2"-LFL-011076305-101CH2F-P
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480213
2"
N2L
011
076302
101CS1P
2"-N2L-011035302-101CS1P-N
SA-JER-DS011-TRJR-480221
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
2"
N2L
011
076302
101CS1P
SA-JER-DS011-TRJR-480213
2"-LFL-011076306-101CH2F-P
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480213
2"
N2L
011
076303
101CS1P
4"-N2L-011074302-101CS1P-N
SA-JER-DS011-TRJR-480221
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480221
2"
N2L
011
076303
101CS1P
SA-JER-DS011-TRJR-480213
2"-LFL-011076307-101CH2F-P
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480212
1"
N2L
011
171301
101CS1P
4"-N2L-011074301-101CS1P-N
Reducer
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX TEMPERATURE
SA-JER-DS011-TRJR-480212
1/2"
N2L
011
171301
101CS1P
Reducer
SA-JER-DS011-TRJR-480251
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX TEMPERATURE
SA-JER-DS011-TRJR-480251
1/2"
N2L
011
171301
101CS1P
SA-JER-DS011-TRJR-480212
011-G-0003-A
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480212
1"
N2L
011
171302
101CS1P
1"-N2L-011171301-101CS1P-N
Reducer
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX TEMPERATURE
SA-JER-DS011-TRJR-480212
1/2"
N2L
011
171302
101CS1P
Reducer
SA-JER-DS011-TRJR-480251
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX TEMPERATURE
SA-JER-DS011-TRJR-480251
1/2"
N2L
011
171302
101CS1P
SA-JER-DS011-TRJR-480212
011-G-0003-B
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480211
1"
N2L
011
230301
101CS1P
4"-N2L-011074301-101CS1P-N
SA-JER-DS011-TRJR-480289
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480289
1"
N2L
011
230301
101CS1P
SA-JER-DS011-TRJR-480211
Blind flange
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480211
1"
N2L
011
230302
101CS1P
4"-N2L-011074301-101CS1P-N
SA-JER-DS011-TRJR-480290
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480290
1"
N2L
011
230302
101CS1P
SA-JER-DS011-TRJR-480211
011-AS-0002
-
-
N
-
NITROGEN
Gas
-
9.00
40.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480004
18"
NAP
011
002001
101CH2S
011-E-0003-A/B/C/D
Reducer
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
18"
NAP
011
002001
101CH2S
011-E-0003-C
Reducer
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
2"
NAP
011
002001
101CH2S
18"-NAP-011002001-101CH2S-P
011-TW-0081
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
2"
NAP
011
002001
101CH2S
18"-NAP-011002001-101CH2S-P
CP
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
2"
NAP
011
002001
101CH2S
18"-NAP-011002001-101CH2S-P
CP
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
18"
NAP
011
002001
101CH2S
011-E-0003-B
Reducer
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
2"
NAP
011
002001
101CH2S
18"-NAP-011002001-101CH2S-P
011-TW-0086
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
2"
NAP
011
002001
101CH2S
18"-NAP-011002001-101CH2S-P
CP
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
2"
NAP
011
002001
101CH2S
18"-NAP-011002001-101CH2S-P
011-TW-0088
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
2"
NAP
011
002001
101CH2S
18"-NAP-011002001-101CH2S-P
CP
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
18"
NAP
011
002001
101CH2S
011-E-0003-D
Reducer
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
24"
NAP
011
002001
101CH2S
Reducer
Reducer
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-380001
Page 127 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
-
TYPE P
FLUID
THICKNESS (mm) 25
PHASE
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480004
2"
NAP
011
002001
101CH2S
24"-NAP-011002001-101CH2S-P
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
2"
NAP
011
002001
101CH2S
24"-NAP-011002001-101CH2S-P
UC
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
2"
NAP
011
002001
101CH2S
24"-NAP-011002001-101CH2S-P
011-TI-0192
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
24"
NAP
011
002001
101CH2S
Reducer
24"-NAP-011002001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
24"
NAP
011
002001
101CH2S
Reducer
Reducer
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
24"
NAP
011
002001
101CH2S
Reducer
24"-NAP-011002001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
2"
NAP
011
002001
101CH2S
24"-NAP-011002001-101CH2S-P
011-TI-0191
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
34"
NAP
011
002001
101CH2S
SA-JER-DS011-TRJR-480004
Reducer
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.54
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
34"
NAP
011
002001
101CH2S
34"-NAP-011002001-101CH2S-P
Reducer
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.54
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
2"
NAP
011
002001
101CH2S
34"-NAP-011002001-101CH2S-P
011-TT-00361
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
20"
NAP
011
002001
101CH2S
Reducer
Reducer
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
20"
NAP
011
002001
101CH2S
Reducer
Reducer
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
20"
NAP
011
002001
101CH2S
20"-NAP-011002001-101CH2S-P
Reducer
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
16"
NAP
011
002001
101CH2S
Reducer
HEADER
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
16"
NAP
011
002001
101CH2S
Reducer
HEADER
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
16"
NAP
011
002001
101CH2S
HEADER
16"-NAP-011002001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
16"
NAP
011
002001
101CH2S
Reducer
HEADER
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
16"
NAP
011
002001
101CH2S
HEADER
16"-NAP-011002001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
16"
NAP
011
002001
101CH2S
HEADER
16"-NAP-011002001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
16"
NAP
011
002001
101CH2S
Reducer
HEADER
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
16"
NAP
011
002001
101CH2S
16"-NAP-011002001-101CH2S-P
HEADER
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
10"
NAP
011
002001
101CH2S
16"-NAP-011002001-101CH2S-P
011-A-0001A/B/C/D/E/F/G/H/I/J/K/L/M/N/O/P
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
10"
NAP
011
002001
101CH2S
16"-NAP-011002001-101CH2S-P
011-A-0001-O
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
10"
NAP
011
002001
101CH2S
16"-NAP-011002001-101CH2S-P
011-A-0001-B
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
10"
NAP
011
002001
101CH2S
16"-NAP-011002001-101CH2S-P
011-A-0001-J
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
10"
NAP
011
002001
101CH2S
16"-NAP-011002001-101CH2S-P
011-A-0001-H
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
10"
NAP
011
002001
101CH2S
16"-NAP-011002001-101CH2S-P
011-A-0001-G
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
10"
NAP
011
002001
101CH2S
16"-NAP-011002001-101CH2S-P
011-A-0001-C
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
10"
NAP
011
002001
101CH2S
16"-NAP-011002001-101CH2S-P
011-A-0001-I
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
10"
NAP
011
002001
101CH2S
16"-NAP-011002001-101CH2S-P
011-A-0001-F
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
10"
NAP
011
002001
101CH2S
16"-NAP-011002001-101CH2S-P
011-A-0001-E
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
10"
NAP
011
002001
101CH2S
16"-NAP-011002001-101CH2S-P
011-A-0001-L
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
10"
NAP
011
002001
101CH2S
16"-NAP-011002001-101CH2S-P
011-A-0001-D
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
10"
NAP
011
002001
101CH2S
16"-NAP-011002001-101CH2S-P
011-A-0001-M
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
10"
NAP
011
002001
101CH2S
16"-NAP-011002001-101CH2S-P
011-A-0001-P
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
10"
NAP
011
002001
101CH2S
16"-NAP-011002001-101CH2S-P
011-A-0001-N
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480045
10"
NAP
011
002001
101CH2S
16"-NAP-011002001-101CH2S-P
011-A-0001-K
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
34"
NAP
011
002001
101CH2S
Reducer
SA-JER-DS011-TRJR-480045
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.54
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
34"
NAP
011
002001
101CH2S
Reducer
34"-NAP-011002001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.54
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
2"
NAP
011
002001
101CH2S
34"-NAP-011002001-101CH2S-P
CP
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
2"
NAP
011
002002
101CH2S
24"-NAP-011002001-101CH2S-P
2"-CLD-011002302-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
2"
NAP
011
002002
101CH2S
2"-NAP-011002002-101CH2S-P
Blind flange
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
2"
NAP
011
002003
101CH2S
24"-NAP-011002001-101CH2S-P
2"-CLD-011002304-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
2"
NAP
011
002003
101CH2S
2"-NAP-011002003-101CH2S-P
Blind flange
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480004
2"
NAP
011
002004
101CH2S
28"-NAP-011018001-101CH2S-P
2"-LFL-011002301-101CH2F-N
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
NAP
011
002004
101CH2S
2"-NAP-011002004-101CH2S-P
Blind flange
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
NAP
011
002009
101CH2S
28"-NAP-011018001-101CH2S-P
2"-LFL-011002301-101CH2F-N
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480004
2"
NAP
011
002009
101CH2S
2"-NAP-011002009-101CH2S-P
Blind flange
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
16"
NAP
011
003001
101CH2S
011-E-0004-A/B
Reducer
-
-
P
25
WET NAPHTHA
Liquid/Gas Mixture
15.5
3.40
110.00
-
170.00
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480005
2"
NAP
011
003001
101CH2S
16"-NAP-011003001-101CH2S-P
Blind flange
-
-
P
25
WET NAPHTHA
Liquid/Gas Mixture
15.5
3.40
110.00
-
170.00
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480005
2"
NAP
011
003001
101CH2S
16"-NAP-011003001-101CH2S-P
011-TI-0014
-
-
P
25
WET NAPHTHA
Liquid/Gas Mixture
15.5
3.40
110.00
-
170.00
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480005
2"
NAP
011
003001
101CH2S
16"-NAP-011003001-101CH2S-P
011-TI-0015
-
-
P
25
WET NAPHTHA
Liquid/Gas Mixture
15.5
3.40
110.00
-
170.00
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480005
16"
NAP
011
003001
101CH2S
011-E-0004-B
Reducer
-
-
P
25
WET NAPHTHA
Liquid/Gas Mixture
15.5
3.40
110.00
-
170.00
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480005
2"
NAP
011
003001
101CH2S
16"-NAP-011003001-101CH2S-P
Blind flange
-
-
P
25
WET NAPHTHA
Liquid/Gas Mixture
15.5
3.40
110.00
-
170.00
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480005
24"
NAP
011
003001
101CH2S
Reducer
SA-JER-DS011-TRJR-480023
-
-
P
25
WET NAPHTHA
Liquid/Gas Mixture
15.5
3.40
110.00
-
170.00
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
UC
-
TEMP. (ºC)
INSULATION (NOTE 2)
DOC. No.
HEAVY NAPHTHA
SA-JER-DS011-TRJR-480005
2"
NAP
011
003001
101CH2S
24"-NAP-011003001-101CH2S-P
011-TT-0016
-
-
P
25
WET NAPHTHA
Liquid/Gas Mixture
15.5
3.40
110.00
-
170.00
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480005
24"
NAP
011
003001
101CH2S
Reducer
24"-NAP-011003001-101CH2S-P
-
-
P
25
WET NAPHTHA
Liquid/Gas Mixture
15.5
3.40
110.00
-
170.00
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480023
24"
NAP
011
003001
101CH2S
SA-JER-DS011-TRJR-480005
011-D-0003
-
-
P
25
WET NAPHTHA
Liquid/Gas Mixture
15.5
3.40
110.00
-
170.00
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480005
2"
NAP
011
003002
101CH2S
16"-NAP-011003001-101CH2S-P
2"-CLD-011003302-101CH2S-P
-
-
P
25
WET NAPHTHA
Liquid/Gas Mixture
15.5
3.40
110.00
-
170.00
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480005
2"
NAP
011
003002
101CH2S
2"-NAP-011003002-101CH2S-P
Blind flange
-
-
P
25
WET NAPHTHA
Liquid/Gas Mixture
15.5
3.40
110.00
-
170.00
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480005
2"
NAP
011
003003
101CH2S
16"-NAP-011003001-101CH2S-P
2"-CLD-011003304-101CH2S-P
-
-
P
25
WET NAPHTHA
Liquid/Gas Mixture
15.5
3.40
110.00
-
170.00
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480005
2"
NAP
011
003003
101CH2S
2"-NAP-011003003-101CH2S-P
Blind flange
-
-
P
25
WET NAPHTHA
Liquid/Gas Mixture
15.5
3.40
110.00
-
170.00
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480005
2"
NAP
011
003005
101CH2S
16"-NAP-011011001-101CH2S-P
2"-LFL-011003001-101CH2F-N
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
NAP
011
003005
101CH2S
2"-NAP-011003005-101CH2S-P
Blind flange
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
NAP
011
003006
101CH2S
16"-NAP-011011001-101CH2S-P
2"-LFL-011003001-101CH2F-N
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480005
2"
NAP
011
003006
101CH2S
2"-NAP-011003006-101CH2S-P
Blind flange
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480020
26"
NAP
011
011001
101CH2S
011-C-0001
Reducer
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.99
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 6
SA-JER-DS011-TRJR-480020
24"
NAP
011
011001
101CH2S
Reducer
SA-JER-DS011-TRJR-480005
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 6
SA-JER-DS011-TRJR-480020
3/4"
NAP
011
011001
101CH2S
24"-NAP-011011001-101CH2S-P
011-PT-0011-B
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 6
24"-NAP-011011001-101CH2S-P
011-TT-0058
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 6
-
P
25
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 6 MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 6
SA-JER-DS011-TRJR-480020
2"
NAP
011
011001
101CH2S
SA-JER-DS011-TRJR-480020
3/4"
NAP
011
011001
101CH2S
24"-NAP-011011001-101CH2S-P
011-PT-0011-C
-
WET NAPHTHA
Gas
SA-JER-DS011-TRJR-480020
3/4"
NAP
011
011001
101CH2S
24"-NAP-011011001-101CH2S-P
011-PT-0011-A
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480005
24"
NAP
011
011001
101CH2S
SA-JER-DS011-TRJR-480020
Reducer
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480005
24"
NAP
011
011001
101CH2S
24"-NAP-011011001-101CH2S-P
Reducer
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480005
16"
NAP
011
011001
101CH2S
Reducer
011-E-0004-A/B
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480005
16"
NAP
011
011001
101CH2S
Reducer
011-E-0004-B
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480020
12"
NAP
011
011001
101CH2S
24"-NAP-011011001-101CH2S-P
011-SP-0022
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200°C. NOTES 6,10
SA-JER-DS011-TRJR-480020
12"
NAP
011
011001
101CH2S
011-SP-0022
Reducer
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200°C. NOTE 10
SA-JER-DS011-TRJR-480020
8"
NAP
011
011001
101CH2S
Reducer
011-PZV-0005-B
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200°C. NOTE 10
SA-JER-DS011-TRJR-480020
3/4"
NAP
011
011001
101CH2S
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200°C. NOTE 10
SA-JER-DS011-TRJR-480020
3/4"
NAP
011
011001
101CH2S 3/4"-NAP-011011001-101CH2S-P
Blind flange
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200°C. NOTE 10
SA-JER-DS011-TRJR-480020
12"
NAP
011
011001
101CH2S
011-SP-0022
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200°C. NOTES 6,10
12"
NAP
011
011001
101CH2S
SA-JER-DS011-TRJR-480020
12"-NAP-011011001-101CH2S-P 3/4"-LFL-011011301-101CH2F-N
24"-NAP-011011001-101CH2S-P
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200°C. NOTE 10
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200°C. NOTE 10
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200°C. NOTE 10
Blind flange
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200°C. NOTE 10
24"-NAP-011011001-101CH2S-P
011-SP-0022
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200°C. NOTES 6,10
011-SP-0022
Reducer
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200°C. NOTE 10
011-SP-0022
Reducer
Reducer
011-PZV-0005-A
SA-JER-DS011-TRJR-480020
8"
NAP
011
011001
101CH2S
SA-JER-DS011-TRJR-480020
3/4"
NAP
011
011001
101CH2S
SA-JER-DS011-TRJR-480020
3/4"
NAP
011
011001
101CH2S 3/4"-NAP-011011001-101CH2S-P
SA-JER-DS011-TRJR-480020
12"
NAP
011
011001
101CH2S
SA-JER-DS011-TRJR-480020
12"
NAP
011
011001
101CH2S
SA-JER-DS011-TRJR-380001
12"-NAP-011011001-101CH2S-P 3/4"-LFL-011011301-101CH2F-N
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 6 MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 6 MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 6 MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 6
Page 128 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
TO
Reducer
011-PZV-0006
SA-JER-DS011-TRJR-480020
8"
NAP
011
011001
101CH2S
SA-JER-DS011-TRJR-480020
3/4"
NAP
011
011001
101CH2S
SA-JER-DS011-TRJR-480020
3/4"
NAP
011
011001
101CH2S 3/4"-NAP-011011001-101CH2S-P
SA-JER-DS011-TRJR-480020
2"
NAP
011
011001
101CH2S
TYPE
TEMP. (ºC)
INSULATION (NOTE 2)
TYPE
FLUID
THICKNESS (mm)
PHASE
(NOTE 3)
DOC. No.
DENSITY (kg/m3)
(NOTE 4)
OPERATING CONDITIONS PRESS. (BARG)
TEMP. (ºC)
DESIGN CONDITIONS
ALTERNATE CONDITIONS PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
(ºC)
TEST CONDITIONS
MEDIUM (NOTE 5)
PRESS. (BARG)
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6)
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200°C. NOTE 10
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200°C. NOTE 10
Blind flange
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200°C. NOTE 10
24"-NAP-011011001-101CH2S-P
2"-NAP-011011001-101CH2S-P
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200°C. NOTES 6,10
12"-NAP-011011001-101CH2S-P 3/4"-LFL-011011301-101CH2F-N
SA-JER-DS011-TRJR-480020
2"
NAP
011
011001
101CH2S
2"-NAP-011011001-101CH2S-P
2"-LFL-011011301-101CH2F-N
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 10
SA-JER-DS011-TRJR-480020
3/4"
NAP
011
011001
101CH2S
2"-NAP-011011001-101CH2S-P
Blind flange
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 10
SA-JER-DS011-TRJR-480020
2"
NAP
011
011003
103CH2S
24"-NAP-011011001-101CH2S-P
011-AT-0036
-
-
P
25
WET NAPHTHA
Gas
-
3.70
137.00
-
-
5.00
175.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR OTHER CASES: 200ºC. NOTE 6
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 bara (HALF VACUUM) @ 200ºC.
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 bara (HALF VACUUM) @ 200ºC.
if insulated N or Q SA-JER-DS011-TRJR-480020
-
NAP
011
011601
101CH2S
011-C-0001
TRIM
-
-
H
-
-
-
-
3.90
188.00
-
-
5.30
278.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480020
6"
NAP
011
011601
101CH2S
011-C-0001
Blind flange
-
-
H
50
-
-
-
3.90
188.00
-
-
5.30
278.00
-
H
8.65
NFS
YES
SA-JER-DS011-TRJR-480023
8"
NAP
011
012001
101CH2S
011-D-0003
SA-JER-DS011-TRJR-480022
-
-
P
25
NAPHTHA
Liquid
622
3.00
110.00
-
-
6.00
140.00
-
H
9.00
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTA 6
SA-JER-DS011-TRJR-480022
8"
NAP
011
012001
101CH2S
SA-JER-DS011-TRJR-480023
8"-NAP-011012001-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
622
3.00
110.00
-
-
6.00
140.00
-
H
9.00
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
4"
NAP
011
012001
101CH2S
4"-NAP-011012021-103CH2S-P
8"-NAP-011012001-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
622
3.00
110.00
-
-
6.00
140.00
-
H
9.00
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
8"
NAP
011
012001
101CH2S
8"-NAP-011012001-101CH2S-P
Reducer
-
-
P
25
NAPHTHA
Liquid
622
3.00
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
3/4"
NAP
011
012001
101CH2S
8"-NAP-011012001-101CH2S-P
UC
-
-
P
25
NAPHTHA
Liquid
622
3.00
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
3/4"
NAP
011
012001
101CH2S
8"-NAP-011012001-101CH2S-P
011-PI-0139
-
-
P
25
NAPHTHA
Liquid
622
3.00
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
6"
NAP
011
012001
101CH2S
Reducer
011-G-0003-A
-
-
P
25
NAPHTHA
Liquid
622
3.00
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
4"
NAP
011
012002
101CH2S
011-G-0003-A
Reducer
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
6"
NAP
011
012002
101CH2S
Reducer
6"-NAP-011012002-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
3/4"
NAP
011
012002
101CH2S
6"-NAP-011012002-101CH2S-P
011-PI-0019
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480020
6"
NAP
011
012002
101CH2S
SA-JER-DS011-TRJR-480022
011-C-0001
-
-
P
25
NAPHTHA
Liquid
622
6.00
110.00
-
-
7.40
140.00
-
H
11.10
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480022
6"
NAP
011
012002
101CH2S
6"-NAP-011012002-101CH2S-P
Reducer
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
1/2"
NAP
011
012002
101CH2S
011-FE-0009
011-FT-0009-B
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
1/2"
NAP
011
012002
101CH2S
011-FE-0009
011-FT-0009-A
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
4"
NAP
011
012002
101CH2S
Reducer
4"-NAP-011012002-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
1/2"
NAP
011
012002
101CH2S
011-FE-0009
011-FT-0009-A
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
1/2"
NAP
011
012002
101CH2S
011-FE-0009
011-FT-0009-B
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
6"
NAP
011
012002
101CH2S
6"-NAP-011012002-101CH2S-P
Reducer
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
4"
NAP
011
012002
101CH2S
Reducer
Reducer
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
6"
NAP
011
012002
101CH2S
Reducer
6"-NAP-011012002-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
6"
NAP
011
012002
101CH2S
6"-NAP-011012002-101CH2S-P
SA-JER-DS011-TRJR-480020
-
-
P
25
NAPHTHA
Liquid
622
6.00
110.00
-
-
7.40
140.00
-
H
11.10
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
6"
NAP
011
012002
101CH2S
Reducer
6"-NAP-011012002-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
622
6.00
110.00
-
-
7.40
140.00
-
H
11.10
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
4"
NAP
011
012002
101CH2S
4"-NAP-011012002-101CH2S-P
Reducer
-
-
P
25
NAPHTHA
Liquid
622
6.00
110.00
-
-
7.40
140.00
-
H
11.10
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480023
12"
NAP
011
012003
101CH2S
011-D-0003
011-SP-0023
-
-
P
25
NAPHTHA
Gas
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480023
12"
NAP
011
012003
101CH2S
011-SP-0023
Reducer
-
-
P
25
NAPHTHA
Gas
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
if NOT insulated B or Q if insulated N or Q if NOT insulated B or Q
SA-JER-DS011-TRJR-480023
6"
NAP
011
012003
101CH2S
Reducer
011-PZV-0008
-
-
P
25
NAPHTHA
Gas
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480023
12"
NAP
011
012003
101CH2S
12"-NAP-011012003-101CH2S-P
011-SP-0023
-
-
P
25
NAPHTHA
Gas
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480023
12"
NAP
011
012003
101CH2S
011-SP-0023
Reducer
-
-
P
25
NAPHTHA
Gas
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480023
6"
NAP
011
012003
101CH2S
Reducer
011-PZV-0007
-
-
P
25
NAPHTHA
Gas
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480023
3/4"
NAP
011
012003
101CH2S
-
-
P
25
NAPHTHA
Gas
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480023
3/4"
NAP
011
012003
101CH2S 3/4"-NAP-011012003-101CH2S-P
-
-
P
25
NAPHTHA
Gas
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480023
3/4"
NAP
011
012003
101CH2S
SA-JER-DS011-TRJR-480023
3/4"
NAP
011
012003
101CH2S 3/4"-NAP-011012003-101CH2S-P
SA-JER-DS011-TRJR-480023
2"
NAP
011
012003
101CH2S
SA-JER-DS011-TRJR-480023
2"
NAP
011
012003
101CH2S
SA-JER-DS011-TRJR-480023
3/4"
NAP
011
012003
101CH2S
SA-JER-DS011-TRJR-480023
20"
NAP
011
012004
101CH2S
SA-JER-DS011-TRJR-480023
1/2"
NAP
011
012004
SA-JER-DS011-TRJR-480023
1/2"
NAP
011
012004
SA-JER-DS011-TRJR-480023
2"
NAP
011
SA-JER-DS011-TRJR-480048
20"
NAP
SA-JER-DS011-TRJR-480048
20"
SA-JER-DS011-TRJR-480048
12"-NAP-011012003-101CH2S-P 3/4"-LFL-011012301-101CH2F-N
Blind flange
NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX TEMPERATURE FOR OTHER CASES: 110ºC. NOTES 6, 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX TEMPERATURE FOR OTHER CASES: 110ºC. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX TEMPERATURE FOR OTHER CASES: 110ºC. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX TEMPERATURE FOR OTHER CASES: 110ºC. NOTES 6,10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX TEMPERATURE FOR OTHER CASES: 110ºC. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX TEMPERATURE FOR OTHER CASES: 110ºC. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX TEMPERATURE FOR OTHER CASES: 110ºC. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX TEMPERATURE FOR OTHER CASES: 110ºC. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX TEMPERATURE FOR OTHER CASES: 110ºC. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX TEMPERATURE FOR OTHER CASES: 110ºC. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX TEMPERATURE FOR OTHER CASES: 110ºC. NOTES 6,10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX TEMPERATURE FOR OTHER CASES: 110ºC. NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX TEMPERATURE FOR OTHER CASES: 110ºC. NOTE 10
-
-
P
25
NAPHTHA
Gas
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
Blind flange
-
-
P
25
NAPHTHA
Gas
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
12"-NAP-011012003-101CH2S-P
2"-NAP-011012003-101CH2S-P
-
-
P
25
NAPHTHA
Gas
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
2"-NAP-011012003-101CH2S-P
2"-LFL-011012301-101CH2F-N
-
-
P
25
NAPHTHA
Gas
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
2"-NAP-011012003-101CH2S-P
Blind flange
-
-
P
25
NAPHTHA
Gas
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
011-D-0003
SA-JER-DS011-TRJR-480048
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
101CH2S
011-FE-0010
011-FT-0010
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
101CH2S
011-FE-0010
011-FT-0010
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
012004
101CH2S
20"-NAP-011012004-101CH2S-P
011-TT-0061
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
011
012004
101CH2S
SA-JER-DS011-TRJR-480023
Reducer
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
NAP
011
012004
101CH2S
20"-NAP-011012004-101CH2S-P
Reducer
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
16"
NAP
011
012004
101CH2S
Reducer
HEADER
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
16"
NAP
011
012004
101CH2S
Reducer
HEADER
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
8"
NAP
011
012004
101CH2S
16"-NAP-011012004-101CH2S-P
011-A-0002-A/B/C
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
8"
NAP
011
012004
101CH2S
8"-NAP-011012004-101CH2S-P
011-A-0002-A/B
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
8"
NAP
011
012004
101CH2S
16"-NAP-011012004-101CH2S-P
011-A-0002-E/F
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
8"
NAP
011
012004
101CH2S
8"-NAP-011012004-101CH2S-P
011-A-0002-C/D
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
8"
NAP
011
012004
101CH2S
8"-NAP-011012004-101CH2S-P
011-A-0002-E/F
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
8"
NAP
011
012004
101CH2S
16"-NAP-011012004-101CH2S-P
011-A-0002-C/D
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
8"
NAP
011
012004
101CH2S
16"-NAP-011012004-101CH2S-P
011-A-0002-C/D
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
8"
NAP
011
012004
101CH2S
8"-NAP-011012004-101CH2S-P
011-A-0002-E/F
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
8"
NAP
011
012004
101CH2S
16"-NAP-011012004-101CH2S-P
011-A-0002-E/F
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
8"
NAP
011
012004
101CH2S
8"-NAP-011012004-101CH2S-P
011-A-0002-A/B
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
8"
NAP
011
012004
101CH2S
8"-NAP-011012004-101CH2S-P
011-A-0002-C/D
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
8"
NAP
011
012004
101CH2S
16"-NAP-011012004-101CH2S-P
011-A-0002-A/B
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
8"
NAP
011
012005
101CH2S
8"-NAP-011012001-101CH2S-P
8"-NAP-011012005-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
622
3.00
110.00
-
-
6.00
140.00
-
H
9.00
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
8"
NAP
011
012005
101CH2S
8"-NAP-011012005-101CH2S-P
Reducer
-
-
P
25
NAPHTHA
Liquid
622
3.00
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
3/4"
NAP
011
012005
101CH2S
8"-NAP-011012005-101CH2S-P
UC
-
-
P
25
NAPHTHA
Liquid
622
3.00
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
3/4"
NAP
011
012005
101CH2S
8"-NAP-011012005-101CH2S-P
011-PI-0147
-
-
P
25
NAPHTHA
Liquid
622
3.00
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
6"
NAP
011
012005
101CH2S
Reducer
011-G-0003-B
-
-
P
25
NAPHTHA
Liquid
622
3.00
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
4"
NAP
011
012006
101CH2S
011-G-0003-B
Reducer
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
6"
NAP
011
012006
101CH2S
Reducer
6"-NAP-011012006-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
3/4"
NAP
011
012006
101CH2S
6"-NAP-011012006-101CH2S-P
011-PI-0020
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
6"
NAP
011
012006
101CH2S
6"-NAP-011012006-101CH2S-P
6"-NAP-011012002-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
12"-NAP-011012003-101CH2S-P 3/4"-LFL-011012301-101CH2F-N
Page 129 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
6"-NAP-011012002-101CH2S-P
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480022
3/4"
NAP
011
012007
101CH2S
Reducer
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
3/4"
NAP
011
012007
101CH2S 3/4"-NAP-011012007-101CH2S-P
Blind flange
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
2"
NAP
011
012007
101CH2S
Reducer
2"-CLD-011012301-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
1-1/2"
NAP
011
012008
101CH2S
6"-NAP-011012002-101CH2S-P
Reducer
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
3/4"
NAP
011
012008
101CH2S
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
2"
NAP
011
012008
101CH2S
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
3/4"
NAP
011
012008
101CH2S
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
1-1/2"
NAP
011
012008
101CH2S
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
1-1/2"
NAP
011
012009
101CH2S
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
25
NAPHTHA
Liquid
622
7.40
110.00
-
-
11.30
140.00
-
H
16.95
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
1-1/2"-NAP-011012008-101CH2S- 3/4"-OLW-011012301-101CS1PP N Reducer
2"-CLD-011012302-101CH2S-P
1-1/2"-NAP-011012008-101CH2SP 1-1/2"-NAP-011012008-101CH2S8"-NAP-011012001-101CH2S-P P 011-G-0003-A
6"-NAP-011012006-101CH2S-P
Reducer
SA-JER-DS011-TRJR-480022
3/4"
NAP
011
012009
SA-JER-DS011-TRJR-480022
2"
NAP
011
012009
1-1/2"-NAP-011012009-101CH2S- 3/4"-OLW-011012302-101CS1P101CH2S P N 101CH2S Reducer 2"-CLD-011012303-101CH2S-P
SA-JER-DS011-TRJR-480022
3/4"
NAP
011
012009
101CH2S
SA-JER-DS011-TRJR-480022
1-1/2"
NAP
011
012009
101CH2S
SA-JER-DS011-TRJR-480023
3/4"
NAP
011
012011
101CH2S
SA-JER-DS011-TRJR-480274
3/4"
NAP
011
012011
101CH2S 3/4"-NPH-011098001-103CH2S-P
SA-JER-DS011-TRJR-480022
3/4"
NAP
011
012012
103CH2S
4"-NAP-011021006-103CH2S-N
SA-JER-DS011-TRJR-480022
2"
NAP
011
012012
103CH2S
SA-JER-DS011-TRJR-480023
3/4"
NAP
011
012016
101CH2S
SA-JER-DS011-TRJR-480023
3/4"
NAP
011
012016
101CH2S 3/4"-NAP-011012016-101CH2S-P
SA-JER-DS011-TRJR-480023
3/4"
NAP
011
012017
101CH2S
SA-JER-DS011-TRJR-480023
3/4"
NAP
011
012017
101CH2S 3/4"-NAP-011012017-101CH2S-P
1-1/2"-NAP-011012009-101CH2SP 1-1/2"-NAP-011012009-101CH2S8"-NAP-011012005-101CH2S-P P 011-G-0003-B
011-SC-0040
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SAMPLE COOLER
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Reducer
-
-
N
-
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
Reducer
2"-CLD-011012306-101CH2S-N
-
-
N
-
NAPHTHA
Liquid
650
7.30
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
011-LG-0005
3/4"-LFL-011012302-101CH2F-N
-
-
P
25
NAPHTHA
Gas
-
3.40
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Blind flange
-
-
P
25
NAPHTHA
Gas
-
3.40
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
3/4"-LFL-011012303-101CH2F-N
-
-
P
25
NAPHTHA
Gas
-
3.40
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Plug
-
-
P
25
NAPHTHA
Gas
-
3.40
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
20"-NAP-011012004-101CH2S-P
011-LDG-0007
NOTE 6
SA-JER-DS011-TRJR-480023
2"
NAP
011
012019
101CH2S
UC
011-D-0003
-
-
P
25
NAPHTHA
Liquid
622
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
N
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: 7 BARG+FV.
SA-JER-DS011-TRJR-480023
3/4"
NAP
011
012019
101CH2S
2"-NAP-011012019-101CH2S-P
Plug
-
-
P
25
NAPHTHA
Liquid
622
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
N
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: 7 BARG+FV.
SA-JER-DS011-TRJR-480022
2"
NAP
011
012020
103CH2S
6"-NAP-011012002-101CH2S-P
011-AT-0032
-
-
P
25
NAPHTHA
Liquid
622
6.00
110.00
-
-
7.40
140.00
-
H
11.10
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
4"
NAP
011
012021
103CH2S
4"-NAP-011021006-103CH2S-N
4"-NAP-011012001-101CH2S-P
-
-
P
25
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
M
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
3/4"
NAP
011
012021
103CH2S
4"-NAP-011012021-103CH2S-P
Blind flange
-
-
P
25
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
M
Y
Y
N
N
N
N
-
NOTE 6
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
if insulated M or Q SA-JER-DS011-TRJR-480023
-
NAP
011
012601
101CH2S
011-D-0003
TRIM
-
-
P
-
-
-
-
3.40
110.00
-
-
5.50
175.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480023
3"
NAP
011
012601
101CH2S
011-D-0003
Blind flange
-
-
P
25
-
-
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
SA-JER-DS011-TRJR-480023
-
NAP
011
012602
103CH2S
011-D-0003
TRIM
-
-
P
-
-
-
-
3.40
110.00
-
-
5.50
175.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480023
2"
NAP
011
012602
103CH2S
011-D-0003
011-LT-0006
-
-
P
25
-
-
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
SA-JER-DS011-TRJR-480023
2"
NAP
011
012602
103CH2S
011-D-0003
011-LT-0004
-
-
P
25
-
-
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
SA-JER-DS011-TRJR-480023
2"
NAP
011
012602
103CH2S
011-D-0003
011-PT-0021
-
-
P
25
-
-
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
SA-JER-DS011-TRJR-480023
2"
NAP
011
012602
103CH2S
011-D-0003
011-LT-0006
-
-
P
25
-
-
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
SA-JER-DS011-TRJR-480023
2"
NAP
011
012602
103CH2S
011-D-0003
011-LT-0004
-
-
P
25
-
-
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
SA-JER-DS011-TRJR-480023
2"
NAP
011
012602
103CH2S
011-D-0003
011-PI-0022
-
-
P
25
-
-
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
SA-JER-DS011-TRJR-480023
2"
NAP
011
012602
103CH2S
011-D-0003
011-LG-0005
-
-
P
25
-
-
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
SA-JER-DS011-TRJR-480023
2"
NAP
011
012602
103CH2S
011-D-0003
011-LG-0005
-
-
P
25
-
-
-
3.40
110.00
-
-
5.50
175.00
-
H
8.25
NFS
YES
SA-JER-DS011-TRJR-480043
40"
NAP
011
018001
101CH2S
011-C-0002
SA-JER-DS011-TRJR-480004
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.68
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018001
101CH2S
40"-NAP-011018001-101CH2S-P
011-PI-0029-C
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
2"
NAP
011
018001
101CH2S
40"-NAP-011018001-101CH2S-P
Flange
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018001
101CH2S
40"-NAP-011018001-101CH2S-P
011-PI-0029-A
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018001
101CH2S
40"-NAP-011018001-101CH2S-P
011-PI-0028
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
SA-JER-DS011-TRJR-480043
2"
NAP
011
018001
101CH2S
40"-NAP-011018001-101CH2S-P
Flange
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018001
101CH2S
40"-NAP-011018001-101CH2S-P
011-PI-0029-B
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480004
40"
NAP
011
018001
101CH2S
SA-JER-DS011-TRJR-480043
Reducer
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.68
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480004
40"
NAP
011
018001
101CH2S
40"-NAP-011018001-101CH2S-P
Reducer
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.68
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480004
28"
NAP
011
018001
101CH2S
Reducer
Reducer
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.68
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480004
28"
NAP
011
018001
101CH2S
28"-NAP-011018001-101CH2S-P
Reducer
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.68
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-380001
MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6
Page 130 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
Reducer
-
-
P
25
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
Gas
-
1.00
119.00
-
-
PRESS. (BARG)
200.00
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
-
H
5.68
NFS
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480004
28"
NAP
011
018001
101CH2S
Reducer
SA-JER-DS011-TRJR-480004
28"
NAP
011
018001
101CH2S
28"-NAP-011018001-101CH2S-P
Reducer
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.68
NFS
YES
SA-JER-DS011-TRJR-480004
18"
NAP
011
018001
101CH2S
Reducer
011-E-0003-A/B/C/D
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
SA-JER-DS011-TRJR-480004
18"
NAP
011
018001
101CH2S
Reducer
011-E-0003-D
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
SA-JER-DS011-TRJR-480004
18"
NAP
011
018001
101CH2S
Reducer
011-E-0003-C
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
SA-JER-DS011-TRJR-480004
18"
NAP
011
018001
101CH2S
Reducer
011-E-0003-B
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
SA-JER-DS011-TRJR-480043
32"
NAP
011
018002
101CH2S
40"-NAP-011018001-101CH2S-P
HEADER
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.68
NFS
SA-JER-DS011-TRJR-480043
14"
NAP
011
018002
101CH2S
32"-NAP-011018002-101CH2S-P
011-SP-0025
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
SA-JER-DS011-TRJR-480043
14"
NAP
011
018002
101CH2S
011-SP-0025
Reducer
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
SA-JER-DS011-TRJR-480043
8"
NAP
011
018002
101CH2S
Reducer
011-PZV-0046-D
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
SA-JER-DS011-TRJR-480043
14"
NAP
011
018002
101CH2S
32"-NAP-011018002-101CH2S-P
011-SP-0025
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
SA-JER-DS011-TRJR-480043
14"
NAP
011
018002
101CH2S
011-SP-0025
Reducer
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
HEAVY NAPHTHA
3.50
TEMP. (ºC)
STRESS TEMP
SA-JER-DS011-TRJR-380001
YES
M
Y
POTENTIAL
N
N
N
N
-
M
Y
POTENTIAL
N
N
N
N
-
M
Y
POTENTIAL
N
N
N
N
-
M
Y
POTENTIAL
N
N
N
N
-
M
Y
POTENTIAL
N
N
N
N
-
YES
M
Y
POTENTIAL
N
N
N
N
-
YES
M
Y
POTENTIAL
N
N
N
N
-
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
8"
NAP
011
018002
101CH2S
Reducer
011-PZV-0046-E
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
14"
NAP
011
018002
101CH2S
32"-NAP-011018002-101CH2S-P
011-SP-0025
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
14"
NAP
011
018002
101CH2S
011-SP-0025
Reducer
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
8"
NAP
011
018002
101CH2S
Reducer
011-PZV-0046-F
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
14"
NAP
011
018002
101CH2S
32"-NAP-011018002-101CH2S-P
011-SP-0025
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
14"
NAP
011
018002
101CH2S
011-SP-0025
Reducer
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
Reducer
011-PZV-0046-G
SA-JER-DS011-TRJR-480043
8"
NAP
011
018002
101CH2S
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018002
101CH2S
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018002
101CH2S 3/4"-NAP-011018002-101CH2S-P
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018002
101CH2S
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018002
101CH2S 3/4"-NAP-011018002-101CH2S-P
SA-JER-DS011-TRJR-480043
14"
NAP
011
018002
101CH2S
32"-NAP-011018002-101CH2S-P
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018002
101CH2S
14"-NAP-011018002-101CH2S-P 3/4"-LFL-011018301-101CH2F-N
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018002
101CH2S 3/4"-NAP-011018002-101CH2S-P
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018002
101CH2S
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018002
101CH2S 3/4"-NAP-011018002-101CH2S-P
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018002
101CH2S
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018002
101CH2S 3/4"-NAP-011018002-101CH2S-P
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018002
101CH2S
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018002
101CH2S 3/4"-NAP-011018002-101CH2S-P
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018002
101CH2S
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018002
101CH2S 3/4"-NAP-011018002-101CH2S-P
SA-JER-DS011-TRJR-480043
14"
NAP
011
018002
101CH2S
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018002
101CH2S
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018002
101CH2S 3/4"-NAP-011018002-101CH2S-P
SA-JER-DS011-TRJR-480043
8"
NAP
011
018002
101CH2S
Reducer
SA-JER-DS011-TRJR-480043
14"
NAP
011
018002
101CH2S
32"-NAP-011018002-101CH2S-P
SA-JER-DS011-TRJR-480043
14"
NAP
011
018002
101CH2S
011-SP-0025
14"-NAP-011018002-101CH2S-P 3/4"-LFL-011018301-101CH2F-N
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
Blind flange
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
011-SP-0025
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
Blind flange
14"-NAP-011018002-101CH2S-P 3/4"-LFL-011018301-101CH2F-N
Blind flange
14"-NAP-011018002-101CH2S-P 3/4"-LFL-011018301-101CH2F-N
Blind flange
14"-NAP-011018002-101CH2S-P 3/4"-LFL-011018301-101CH2F-N
Blind flange
14"-NAP-011018002-101CH2S-P 3/4"-LFL-011018301-101CH2F-N
Blind flange
14"-NAP-011018002-101CH2S-P 3/4"-LFL-011018301-101CH2F-N
011-SP-0025
-
-
Blind flange
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
Blind flange
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
011-PZV-0047
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
011-SP-0025
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
Reducer
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
Reducer
14"-NAP-011018002-101CH2S-P 3/4"-LFL-011018301-101CH2F-N
SA-JER-DS011-TRJR-480043
8"
NAP
011
018002
101CH2S
Reducer
011-PZV-0046-A
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
14"
NAP
011
018002
101CH2S
32"-NAP-011018002-101CH2S-P
011-SP-0025
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
14"
NAP
011
018002
101CH2S
011-SP-0025
Reducer
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
8"
NAP
011
018002
101CH2S
Reducer
011-PZV-0046-B
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
14"
NAP
011
018002
101CH2S
32"-NAP-011018002-101CH2S-P
011-SP-0025
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
14"
NAP
011
018002
101CH2S
011-SP-0025
Reducer
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTES 6, 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTES 6, 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTES 6, 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTES 6, 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTES 6, 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTES 6, 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTES 6, 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTES 6, 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTES 6, 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 10
SA-JER-DS011-TRJR-480043
8"
NAP
011
018002
101CH2S
Reducer
011-PZV-0046-C
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018003
101CH2S
6"-NAP-011019007-101CH2S-P
Reducer
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
018003
101CH2S 3/4"-NAP-011018003-101CH2S-P
Blind flange
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 131 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
INSULATION (NOTE 2)
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
DESIGN CONDITIONS
ALTERNATE CONDITIONS
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
(ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480043
2"
NAP
011
018003
101CH2S
Reducer
2"-CLD-011018306-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
2"
NAP
011
018004
103CH2S
40"-NAP-011018001-101CH2S-P
011-AT-0033
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
4"
NAP
011
018005
101CH2S
4"-N2L-011018301-101CS1P-N
011-ZV-0123
-
-
N
-
FUEL GAS
Gas
-
9.00
40.00
-
-
12.00
80.00
-
H
18.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
6"
NAP
011
018005
101CH2S
4"-NAP-011018005-101CH2S-N
011-ZV-0122
-
-
N
-
FUEL GAS
Gas
-
9.00
40.00
-
-
12.00
80.00
-
H
18.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
6"
NAP
011
018005
101CH2S
011-ZV-0122
4"-NAP-011018005-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
4"
NAP
011
018005
101CH2S
011-ZV-0123
Reducer
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480043
8"
NAP
011
018005
101CH2S
Reducer
40"-NAP-011018001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Gas
-
1.00
119.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200°C
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200°C
NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 285°C MAX. TEMPERATURE FOR OTHER CASES: 360°C NOTE 6
if insulated N or Q SA-JER-DS011-TRJR-480043
-
NAP
011
018601
101CH2S
011-C-0002
TRIM
-
-
H
-
-
-
-
1.60
354.00
-
-
4.10
390.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480043
6"
NAP
011
018601
101CH2S
011-C-0002
Blind flange
-
-
H
100
-
-
-
1.60
354.00
-
-
4.10
390.00
-
H
8.71
NFS
YES
10"
NAP
011
019001
101CH2S
if NOT insulated C or Q if insulated N or Q if NOT insulated C or Q
HEADER
Reducer
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
2"
NAP
011
019001
101CH2S
Blind flange
10"-NAP-011019001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
3/4"
NAP
011
019001
101CH2S
2"-NAP-011019001-101CH2S-P
Blind flange
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
2"
NAP
011
019001
101CH2S
Blind flange
10"-NAP-011019001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
3/4"
NAP
011
019001
101CH2S
2"-NAP-011019001-101CH2S-P
Blind flange
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
10"
NAP
011
019001
101CH2S
HEADER
Reducer
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
12"
NAP
011
019001
101CH2S
Reducer
SA-JER-DS011-TRJR-480046
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
12"
NAP
011
019001
101CH2S
Reducer
12"-NAP-011019001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
2"
NAP
011
019001
101CH2S
12"-NAP-011019001-101CH2S-P
011-TT-0114
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
12"
NAP
011
019001
101CH2S
SA-JER-DS011-TRJR-480045
011-D-0004
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
4"
NAP
011
019001
101CH2S
4"-NAP-011021003-103CH2S-P
12"-NAP-011019001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
12"
NAP
011
019002
101CH2S
011-D-0004
SA-JER-DS011-TRJR-480047
-
-
P
25
NAPHTHA
Liquid
680
0.30
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
12"
NAP
011
019002
101CH2S
SA-JER-DS011-TRJR-480046
12"-NAP-011019002-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
0.30
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
12"
NAP
011
019002
101CH2S
12"-NAP-011019013-101CH2S-P
Reducer
-
-
P
25
NAPHTHA
Liquid
680
0.30
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
3/4"
NAP
011
019002
101CH2S
12"-NAP-011019002-101CH2S-P
011-PI-0179
-
-
P
25
NAPHTHA
Liquid
680
0.30
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
2"
NAP
011
019002
101CH2S
12"-NAP-011019002-101CH2S-P
UC
-
-
P
25
NAPHTHA
Liquid
680
0.30
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
8"
NAP
011
019002
101CH2S
Reducer
011-G-0005-B
-
-
P
25
NAPHTHA
Liquid
680
0.30
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
6"
NAP
011
019003
101CH2S
011-G-0005-A
Reducer
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
8"
NAP
011
019003
101CH2S
Reducer
8"-NAP-011019003-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
3/4"
NAP
011
019003
101CH2S
8"-NAP-011019003-101CH2S-P
011-PI-0036
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480049
6"
NAP
011
019003
101CH2S
SA-JER-DS011-TRJR-480047
6"-NAP-011019003-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
2.40
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480049
6"
NAP
011
019003
101CH2S
6"-NAP-011019003-101CH2S-P
12"-NAP-011020001-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
8"
NAP
011
019003
101CH2S
8"-NAP-011019003-101CH2S-P
Reducer
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
6"
NAP
011
019003
101CH2S
Reducer
Reducer
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
4"
NAP
011
019003
101CH2S
Reducer
4"-NAP-011019003-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
1/2"
NAP
011
019003
101CH2S
011-FT-0025
011-FE-0025
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
6"
NAP
011
019003
101CH2S
6"-NAP-011019003-101CH2S-P
Reducer
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
1/2"
NAP
011
019003
101CH2S
011-FT-0025
011-FE-0025
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
4"
NAP
011
019003
101CH2S
Reducer
Reducer
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
6"
NAP
011
019003
101CH2S
Reducer
6"-NAP-011019003-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
6"
NAP
011
019003
101CH2S
6"-NAP-011019003-101CH2S-P
SA-JER-DS011-TRJR-480049
-
-
P
25
NAPHTHA
Liquid
680
2.40
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
4"
NAP
011
019003
101CH2S
4"-NAP-011019003-101CH2S-P
Reducer
-
-
P
25
NAPHTHA
Liquid
680
2.40
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
6"
NAP
011
019003
101CH2S
Reducer
6"-NAP-011019003-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
2.40
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
4"
NAP
011
019004
101CH2S
011-D-0004
SA-JER-DS011-TRJR-480113
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
5.00
110.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480113
4"
NAP
011
019004
101CH2S
SA-JER-DS011-TRJR-480046
011-D-0006
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
5.00
110.00
-
H
7.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
6"
NAP
011
019005
101CH2S
011-D-0004
6"-NAP-011019005-101CH2S-P
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3"
NAP
011
019005
101CH2S
3"-FGS-011019301-101CS2P-S
Reducer
S
36.8
H
25
NAPHTHA
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
YES
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3"
NAP
011
019005
101CH2S
3"-NAP-011019005-101CH2S-S
Reducer
S
36.8
H
25
NAPHTHA
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
YES
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
1-1/2"
NAP
011
019005
101CH2S
Reducer
Insul Brk
S
36.8
H
25
NAPHTHA
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
YES
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
2"
NAP
011
019005
101CH2S
Reducer
Reducer
S
36.8
H
25
NAPHTHA
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
YES
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
6"
NAP
011
019005
101CH2S
Reducer
Insul Brk
S
36.8
H
40
NAPHTHA
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
YES
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
6"
NAP
011
019005
101CH2S
Insul Brk
6"-NAP-011019005-101CH2S-P
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
1-1/2"
NAP
011
019005
101CH2S
Insul Brk
Reducer
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3"
NAP
011
019005
101CH2S
Reducer
6"-NAP-011019005-101CH2S-P
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
6"
NAP
011
019005
101CH2S
6"-NAP-011019005-101CH2S-P
6"-LFL-011019301-101CH2F-N
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
1/2"
NAP
011
019005
101CH2S
011-FE-0114
011-FT-0114
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
1/2"
NAP
011
019005
101CH2S
011-FE-0114
011-FT-0114
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
6"
NAP
011
019005
101CH2S
6"-NAP-011019005-101CH2S-P
6"-LFL-011019301-101CH2F-N
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
24"
NAP
011
019006
101CH2S
011-D-0004
HEADER
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX. TEMPERATURE FOR OTHER CASES: 126°C NOTES 6, 10
SA-JER-DS011-TRJR-480046
3/4"
NAP
011
019006
101CH2S
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3/4"
NAP
011
019006
101CH2S 3/4"-NAP-011019006-101CH2S-P
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3/4"
NAP
011
019006
101CH2S
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3/4"
NAP
011
019006
101CH2S 3/4"-NAP-011019006-101CH2S-P
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3/4"
NAP
011
019006
101CH2S
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480046
3/4"
NAP
011
019006
101CH2S 3/4"-NAP-011019006-101CH2S-P
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480045
18"-NAP-011019006-101CH2S-P 3/4"-LFL-011019302-101CH2F-N Blind flange
18"-NAP-011019006-101CH2S-P 3/4"-LFL-011019302-101CH2F-N Blind flange
18"-NAP-011019006-101CH2S-P 3/4"-LFL-011019302-101CH2F-N
SA-JER-DS011-TRJR-480046
18"
NAP
011
019006
101CH2S
24"-NAP-011019006-101CH2S-P
SA-JER-DS011-TRJR-480046
18"
NAP
011
019006
101CH2S
SA-JER-DS011-TRJR-480046
8"
NAP
011
019006
101CH2S
SA-JER-DS011-TRJR-480046
18"
NAP
011
019006
101CH2S
SA-JER-DS011-TRJR-480046
18"
NAP
011
019006
101CH2S
Blind flange 011-SP-0026
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
011-SP-0026
Reducer
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
Reducer
011-PZV-0012
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
24"-NAP-011019006-101CH2S-P
011-SP-0026
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
011-SP-0026
Reducer
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
Reducer
011-PZV-0011-A
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480046
8"
NAP
011
019006
101CH2S
SA-JER-DS011-TRJR-480046
18"
NAP
011
019006
101CH2S
24"-NAP-011019006-101CH2S-P
011-SP-0026
-
SA-JER-DS011-TRJR-480046
18"
NAP
011
019006
101CH2S
011-SP-0026
Reducer
-
SA-JER-DS011-TRJR-380001
NOTE 6 NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX. TEMPERATURE FOR OTHER CASES: 126°C NOTE 10. NOTE 6 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX. TEMPERATURE FOR OTHER CASES: 126°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX. TEMPERATURE FOR OTHER CASES: 126°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX. TEMPERATURE FOR OTHER CASES: 126°C NOTES 6, 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX. TEMPERATURE FOR OTHER CASES: 126°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX. TEMPERATURE FOR OTHER CASES: 126°C NOTE 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX. TEMPERATURE FOR OTHER CASES: 126°C NOTES 6, 10 MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX. TEMPERATURE FOR OTHER CASES: 126°C NOTE 10
Page 132 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480046
8"
NAP
011
019006
101CH2S
Reducer
011-PZV-0011-B
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE DURING FIRE SCENARIO: 145°C MAX. TEMPERATURE FOR OTHER CASES: 126°C NOTE 10
SA-JER-DS011-TRJR-480047
6"
NAP
011
019007
101CH2S
8"-NAP-011019003-101CH2S-P
SA-JER-DS011-TRJR-480043
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
6"
NAP
011
019007
101CH2S
SA-JER-DS011-TRJR-480047
Reducer
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
6"
NAP
011
019007
101CH2S
Reducer
6"-NAP-011019007-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
4"
NAP
011
019007
101CH2S
4"-NAP-011019007-101CH2S-P
Reducer
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
1/2"
NAP
011
019007
101CH2S
011-FE-0019
011-FT-0019
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
1/2"
NAP
011
019007
101CH2S
011-FE-0019
011-FT-0019
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
4"
NAP
011
019007
101CH2S
Reducer
Reducer
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
6"
NAP
011
019007
101CH2S
Reducer
6"-NAP-011019007-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
6"
NAP
011
019007
101CH2S
6"-NAP-011019007-101CH2S-P
011-C-0002
-
-
P
25
NAPHTHA
Liquid
680
5.70
65.00
-
-
7.50
100.00
-
H
11.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
6"
NAP
011
019007
101CH2S
6"-NAP-011019007-101CH2S-P
Reducer
-
-
P
25
NAPHTHA
Liquid
680
5.70
65.00
-
-
7.50
100.00
-
H
11.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
4"
NAP
011
019007
101CH2S
Reducer
4"-NAP-011019007-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
5.70
65.00
-
-
7.50
100.00
-
H
11.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
3"
NAP
011
019008
101CH2S
6"-NAP-011019007-101CH2S-P
011-RO-0013
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
3"
NAP
011
019008
101CH2S
011-RO-0013
SA-JER-DS011-TRJR-480043
-
-
P
25
NAPHTHA
Liquid
680
1.00
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
3"
NAP
011
019008
101CH2S
SA-JER-DS011-TRJR-480047
3"-NAP-011019008-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
1.00
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
019008
101CH2S
3"-NAP-011019008-101CH2S-P
Plug
-
-
P
25
NAPHTHA
Liquid
680
1.00
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
3"
NAP
011
019008
101CH2S
3"-NAP-011019008-101CH2S-P
40"-NAP-011018001-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
1.00
65.00
-
-
3.50
200.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
2"
NAP
011
019009
101CH2S
10"-NAP-011019001-101CH2S-P
2"-CLD-011019306-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
1-1/2"
NAP
011
019009
101CH2S
2"-NAP-011019009-101CH2S-P
Blind flange
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
3/4"
NAP
011
019009
101CH2S
2"-NAP-011019009-101CH2S-P
3/4"-OLW-011019301-101CS1PN
SA-JER-DS011-TRJR-480047
12"
NAP
011
019013
101CH2S
12"-NAP-011019002-101CH2S-P
Reducer
-
-
P
25
NAPHTHA
Liquid
680
0.30
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
2"
NAP
011
019013
101CH2S
12"-NAP-011019013-101CH2S-P
UC
-
-
P
25
NAPHTHA
Liquid
680
0.30
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
3/4"
NAP
011
019013
101CH2S
12"-NAP-011019013-101CH2S-P
011-PI-0176
-
-
P
25
NAPHTHA
Liquid
680
0.30
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
8"
NAP
011
019013
101CH2S
Reducer
011-G-0005-A
-
-
P
25
NAPHTHA
Liquid
680
0.30
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
6"
NAP
011
019014
101CH2S
011-G-0005-B
Reducer
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
8"
NAP
011
019014
101CH2S
Reducer
8"-NAP-011019014-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
3/4"
NAP
011
019014
101CH2S
8"-NAP-011019014-101CH2S-P
011-PI-0037
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
8"
NAP
011
019014
101CH2S
8"-NAP-011019014-101CH2S-P
8"-NAP-011019003-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
2"
NAP
011
019016
101CH2S
8"-NAP-011019003-101CH2S-P
2"-CLD-011019302-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
3/4"
NAP
011
019016
101CH2S
2"-NAP-011019016-101CH2S-P
3/4"-OLW-011019303-101CS1PN
SA-JER-DS011-TRJR-480047
2"
NAP
011
019016
101CH2S
12"-NAP-011019013-101CH2S-P
2"-NAP-011019016-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
3/4"
NAP
011
019016
101CH2S
011-G-0005-A
Reducer
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
1"
NAP
011
019016
101CH2S
Reducer
2"-NAP-011019016-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
2"
NAP
011
019017
101CH2S
8"-NAP-011019014-101CH2S-P
2"-CLD-011019303-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
3/4"
NAP
011
019017
101CH2S
2"-NAP-011019017-101CH2S-P
3/4"-OLW-011019304-101CS1PN
SA-JER-DS011-TRJR-480047
2"
NAP
011
019017
101CH2S
12"-NAP-011019002-101CH2S-P
2"-NAP-011019017-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
3/4"
NAP
011
019017
101CH2S
011-G-0005-B
Reducer
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
1"
NAP
011
019017
101CH2S
Reducer
2"-NAP-011019017-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
3/4"
NAP
011
019018
101CH2S
6"-NAP-011019003-101CH2S-P
Reducer
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
3/4"
NAP
011
019018
101CH2S 3/4"-NAP-011019018-101CH2S-P
Plug
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
2"
NAP
011
019018
101CH2S
Reducer
2"-CLD-011019304-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480047
3/4"
NAP
011
019018
101CH2S
6"-NAP-011019003-101CH2S-P
3/4"-NAP-011019018-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480275
3/4"
NAP
011
019019
101CH2S
6"-NPH-011019003-101CH2S-P
SAMPLE COOLER
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. NOTE 6.
SA-JER-DS011-TRJR-480047
3/4"
NAP
011
019019
101CH2S
6"-NAP-011019003-101CH2S-P
011-SC-0006
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480275
3/4"
NAP
011
019020
101CH2S 3/4"-NAP-011200003-101CH2S-N
6"-NPH-011019003-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
2.40
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
NAP
011
019020
101CH2S 3/4"-NAP-011019020-101CH2S-P
Liquid
680
2.40
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/2"
NAP
011
019020
101CH2S
Reducer
Reducer
-
-
P
25
NAPHTHA
Liquid
680
2.40
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
NAP
011
019020
101CH2S
Reducer
3/4"-LFL-011200306-101CH2F-N
-
-
P
25
NAPHTHA
Liquid
680
2.40
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
NAP
011
019020
101CH2S 3/4"-NAP-011019020-101CH2S-P
Plug
-
-
P
25
NAPHTHA
Liquid
680
2.40
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/4"
NAP
011
019020
101CH2S
SAMPLE CYLINDER
Reducer
-
-
P
25
NAPHTHA
Liquid
680
2.40
65.00
-
-
13.00
100.00
-
-
-
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/2"
NAP
011
019020
101CH2S
Reducer
1/2"-NAP-011019020-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
2.40
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480047
3/4"
NAP
011
019020
101CH2S
011-SC-0006
6"-NAP-011019003-101CH2S-P
-
-
P
25
NAPHTHA
Liquid
680
2.40
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480045
2"
NAP
011
019022
101CH2S
20"-NAP-011002001-101CH2S-P
2"-LFL-011019303-101CH2F-N
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
Reducer
-
-
P
25
NAPHTHA
SA-JER-DS011-TRJR-480045
2"
NAP
011
019022
101CH2S
2"-NAP-011019022-101CH2S-P
Blind flange
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480046
3/4"
NAP
011
019023
103CH2S
4"-NAP-011021003-103CH2S-N
Reducer
-
-
N
-
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
2"
NAP
011
019023
103CH2S
Reducer
2"-CLD-011019308-101CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3/4"
NAP
011
019024
101CH2S
011-LG-0023
3/4"-LFL-011019304-101CH2F-N
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3/4"
NAP
011
019024
101CH2S 3/4"-NAP-011019024-101CH2S-P
Blind flange
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
2"
NAP
011
019025
101CH2S
UC
011-D-0004
-
-
P
25
NAPHTHA
Liquid
696.8
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: 7 BARG FV@290ºC.
SA-JER-DS011-TRJR-480046
3/4"
NAP
011
019025
Blind flange
-
-
P
25
NAPHTHA
Liquid
696.8
0.30
65.00
-
100.00
-
NFS
YES
M
101CH2S
2"-NAP-011019025-101CH2S-P
-
3.50
H
5.25
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: 7 BARG FV@290ºC.
SA-JER-DS011-TRJR-480047
2"
NAP
011
019026
103CH2S
6"-NAP-011019007-101CH2S-P
011-AT-0034
-
-
P
25
NAPHTHA
Liquid
680
7.50
65.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3/4"
NAP
011
019027
101CH2S
011-LDG-0025
011-LDG-0025
-
-
P
25
NAPHTHA
Liquid
680
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3/4"
NAP
011
019027
101CH2S 3/4"-NAP-011019027-101CH2S-P
Blind flange
-
-
P
25
NAPHTHA
Liquid
680
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3/4"
NAP
011
019029
101CH2S
3/4"-LFL-011019306-101CH2F-N
-
-
P
25
NAPHTHA
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
YES
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3/4"
NAP
011
019029
101CH2S 3/4"-NAP-011019029-101CH2S-P
Blind flange
-
-
P
25
NAPHTHA
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
YES
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3/4"
NAP
011
019029
101CH2S
3"-NAP-011019005-101CH2S-S
3/4"-NAP-011019029-101CH2S-P
-
-
P
25
NAPHTHA
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
YES
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3/4"
NAP
011
019030
101CH2S
6"-NAP-011019005-101CH2S-P
3/4"-LFL-011019307-101CH2F-N
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
3/4"
NAP
011
019030
101CH2S
6"-NAP-011019005-101CH2S-P
3/4"-NAP-011019030-101CH2S-P
-
-
P
25
NAPHTHA
Gas
-
0.30
65.00
-
-
3.50
100.00
-
H
5.25
NFS
YES
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
6"
NAP
011
019031
101CH2S
011-A-0001A/B/C/D/E/F/G/H/I/J/K/L/M/N/O/P
10"-NAP-011019001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
6"
NAP
011
019031
101CH2S
011-A-0001-K
10"-NAP-011019001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
6"
NAP
011
019031
101CH2S
011-A-0001-M
10"-NAP-011019001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
6"
NAP
011
019031
101CH2S
011-A-0001-O
10"-NAP-011019001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
6"
NAP
011
019031
101CH2S
011-A-0001-C
10"-NAP-011019001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
6"
NAP
011
019031
101CH2S
011-A-0001-B
10"-NAP-011019001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
6"
NAP
011
019031
101CH2S
011-A-0001-F
10"-NAP-011019001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
6"
NAP
011
019031
101CH2S
011-A-0001-G
10"-NAP-011019001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
6"
NAP
011
019031
101CH2S
011-A-0001-L
10"-NAP-011019001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
6"
NAP
011
019031
101CH2S
011-A-0001-J
10"-NAP-011019001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
6"
NAP
011
019031
101CH2S
011-A-0001-D
10"-NAP-011019001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
6"
NAP
011
019031
101CH2S
011-A-0001-I
10"-NAP-011019001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
6"
NAP
011
019031
101CH2S
011-A-0001-E
10"-NAP-011019001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
6"
NAP
011
019031
101CH2S
011-A-0001-H
10"-NAP-011019001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
6"
NAP
011
019031
101CH2S
011-A-0001-N
10"-NAP-011019001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
6"
NAP
011
019031
101CH2S
011-A-0001-P
10"-NAP-011019001-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
2"
NAP
011
019032
101CH2S
20"-NAP-011002001-101CH2S-P
2"-NAP-011019022-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
2"
NAP
011
019032
101CH2S
2"-NAP-011019032-101CH2S-P
Blind flange
-
-
P
25
HEAVY NAPHTHA
Liquid/Gas Mixture
5.51
0.60
94.70
-
-
3.50
160.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
1-1/2"
NAP
011
019033
101CH2S
011-A-0001-A
2"-NAP-011019009-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
6"-NAP-011019005-101CH2S-S
Page 133 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
TO 1-1/2"-NAP-011019033-101CH2SP 1-1/2"-NAP-011019033-101CH2SP 1-1/2"-NAP-011019033-101CH2SP 1-1/2"-NAP-011019033-101CH2SP 1-1/2"-NAP-011019033-101CH2SP 1-1/2"-NAP-011019033-101CH2SP 1-1/2"-NAP-011019033-101CH2SP
INSULATION (NOTE 2)
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
-
-
P
25
-
-
P
25
-
-
P
-
-
-
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
-
-
P
25
HEAVY NAPHTHA
Liquid
-
-
P
25
HEAVY NAPHTHA
-
-
P
25
-
-
P
-
-
-
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
(NOTE 7)
SA-JER-DS011-TRJR-480045
1-1/2"
NAP
011
019033
101CH2S
011-A-0001-C
SA-JER-DS011-TRJR-480045
1-1/2"
NAP
011
019033
101CH2S
011-A-0001-E
SA-JER-DS011-TRJR-480045
1-1/2"
NAP
011
019033
101CH2S
011-A-0001-G
SA-JER-DS011-TRJR-480045
1-1/2"
NAP
011
019033
101CH2S
011-A-0001-F
SA-JER-DS011-TRJR-480045
1-1/2"
NAP
011
019033
101CH2S
011-A-0001-D
SA-JER-DS011-TRJR-480045
1-1/2"
NAP
011
019033
101CH2S
011-A-0001-B
SA-JER-DS011-TRJR-480045
1-1/2"
NAP
011
019033
101CH2S
011-A-0001-H
SA-JER-DS011-TRJR-480045
1-1/2"
NAP
011
019034
101CH2S
011-A-0001-P
SA-JER-DS011-TRJR-480045
1-1/2"
NAP
011
019034
101CH2S
011-A-0001-I
SA-JER-DS011-TRJR-480045
1-1/2"
NAP
011
019034
101CH2S
011-A-0001-J
SA-JER-DS011-TRJR-480045
1-1/2"
NAP
011
019034
101CH2S
011-A-0001-N
SA-JER-DS011-TRJR-480045
1-1/2"
NAP
011
019034
101CH2S
011-A-0001-K
SA-JER-DS011-TRJR-480045
1-1/2"
NAP
011
019034
101CH2S
011-A-0001-L
SA-JER-DS011-TRJR-480045
1-1/2"
NAP
011
019034
101CH2S
011-A-0001-M
SA-JER-DS011-TRJR-480045
1-1/2"
NAP
011
019034
101CH2S
011-A-0001-O
SA-JER-DS011-TRJR-480045
2"
NAP
011
019035
101CH2S
10"-NAP-011019001-101CH2S-P
2"-CLD-011019306-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
1-1/2"
NAP
011
019035
101CH2S
2"-NAP-011019035-101CH2S-P
Blind flange
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480045
3/4"
NAP
011
019035
101CH2S
2"-NAP-011019035-101CH2S-P
3/4"-OLW-011019306-101CS1PN
-
-
P
25
HEAVY NAPHTHA
Liquid
696.8
0.40
65.00
-
-
3.50
130.00
-
H
5.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
2"-NAP-011019035-101CH2S-P 1-1/2"-NAP-011019034-101CH2SP 1-1/2"-NAP-011019034-101CH2SP 1-1/2"-NAP-011019034-101CH2SP 1-1/2"-NAP-011019034-101CH2SP 1-1/2"-NAP-011019034-101CH2SP 1-1/2"-NAP-011019034-101CH2SP 1-1/2"-NAP-011019034-101CH2SP
if insulated M or Q SA-JER-DS011-TRJR-480046
-
NAP
011
019601
101CH2S
011-D-0004
TRIM
-
-
N
-
-
-
-
0.30
65.00
-
-
3.50
100.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480046
-
NAP
011
019602
103CH2S
011-D-0004
TRIM
-
-
N
-
-
-
-
0.30
65.00
-
-
3.50
100.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480048
6"
NAP
011
020001
101CH2S
011-A-0002-A/B
10"-NAP-011020001-101CH2S-P
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480048
6"
NAP
011
020001
101CH2S
011-A-0002-E/F
10"-NAP-011020001-101CH2S-P
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480048
3/4"
NAP
011
020001
101CH2S
2"-NAP-011020001-101CH2S-P
Blind flange
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480048
6"
NAP
011
020001
101CH2S
011-A-0002-A/B
10"-NAP-011020001-101CH2S-P
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480048
6"
NAP
011
020001
101CH2S
011-A-0002-C/D
10"-NAP-011020001-101CH2S-P
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480048
2"
NAP
011
020001
101CH2S
UC
6"-NAP-011020001-101CH2S-P
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
SA-JER-DS011-TRJR-480048
6"
NAP
011
020001
101CH2S
011-A-0002-E/F
10"-NAP-011020001-101CH2S-P
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480048
3/4"
NAP
011
020001
101CH2S
2"-NAP-011020001-101CH2S-P
Blind flange
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480048
6"
NAP
011
020001
101CH2S
011-A-0002-C/D
10"-NAP-011020001-101CH2S-P
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480048
2"
NAP
011
020001
101CH2S
UC
6"-NAP-011020001-101CH2S-P
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480048
10"
NAP
011
020001
101CH2S
HEADER
Reducer
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480048
10"
NAP
011
020001
101CH2S
HEADER
Reducer
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480048
3/4"
NAP
011
020001
101CH2S
Blind flange
2"-NAP-011020001-101CH2S-P
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480048
2"
NAP
011
020001
101CH2S
UC
10"-NAP-011020001-101CH2S-P
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480048
2"
NAP
011
020001
101CH2S
UC
10"-NAP-011020001-101CH2S-P
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480048
3/4"
NAP
011
020001
101CH2S
Blind flange
2"-NAP-011020001-101CH2S-P
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480049
12"
NAP
011
020001
101CH2S
SA-JER-DS011-TRJR-480048
12"-NAP-011020001-101CH2S-P
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480049
12"
NAP
011
020001
101CH2S
12"-NAP-011020001-101CH2S-P
011-E-0021
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
127
2.70
71.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480049
2"
NAP
011
020001
101CH2S
12"-NAP-011020001-101CH2S-P
011-TT-0340
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
127
2.70
71.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480048
12"
NAP
011
020001
101CH2S
Reducer
SA-JER-DS011-TRJR-480049
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480048
12"
NAP
011
020001
101CH2S
Reducer
12"-NAP-011020001-101CH2S-P
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480048
2"
NAP
011
020001
101CH2S
12"-NAP-011020001-101CH2S-P
011-TT-0116
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6, 7
SA-JER-DS011-TRJR-480049
12"
NAP
011
020002
101CH2S
011-E-0021
Reducer
-
-
N
-
NAPHTHA
Liquid
668
2.00
43.00
-
-
6.00
105.00
-
H
9.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480049
10"
NAP
011
020002
101CH2S
Reducer
SA-JER-DS011-TRJR-480050
-
-
N
-
NAPHTHA
Liquid
668
2.00
43.00
-
-
6.00
105.00
-
H
9.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
10"
NAP
011
020002
101CH2S
SA-JER-DS011-TRJR-480049
011-D-0005
-
-
N
-
NAPHTHA
Liquid
668
2.00
43.00
-
-
6.00
105.00
-
H
9.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
1-1/2"
NAP
011
020003
101CH2S
011-A-0002-A/B
Reducer
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
1-1/2"
NAP
011
020003
101CH2S
011-A-0002-A/B
1-1/2"-NAP-011020003-101CH2SP
SA-JER-DS011-TRJR-480048
2"
NAP
011
020003
101CH2S
Reducer
2"-NAP-011020003-101CH2S-P
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
2"
NAP
011
020003
101CH2S
10"-NAP-011020001-101CH2S-P
2"-CLD-011020301-101CH2S-P
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
2"
NAP
011
020003
101CH2S
2"-NAP-011020003-101CH2S-P
3/4"-OLW-011020302-101CS1PN
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
1-1/2"
NAP
011
020003
101CH2S
2"-NAP-011020003-101CH2S-P
Blind flange
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
2"
NAP
011
020005
101CH2S
16"-NAP-011012004-101CH2S-P
2"-LFL-011020301-101CH2F-N
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
2"
NAP
011
020005
101CH2S
2"-NAP-011020005-101CH2S-P
Blind flange
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
2"
NAP
011
020005
101CH2S
2"-NAP-011020006-101CH2S-P
2"-NAP-011020005-101CH2S-P
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
2"
NAP
011
020006
101CH2S
16"-NAP-011012004-101CH2S-P
2"-NAP-011020007-101CH2S-P
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
2"
NAP
011
020006
101CH2S
2"-NAP-011020006-101CH2S-P
Blind flange
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
2"
NAP
011
020007
101CH2S
8"-NAP-011012004-101CH2S-P
2"-NAP-011020006-101CH2S-P
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
2"
NAP
011
020007
101CH2S
2"-NAP-011020007-101CH2S-P
Blind flange
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
2"
NAP
011
020008
101CH2S
8"-NAP-011012004-101CH2S-P
2"-NAP-011020005-101CH2S-P
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
2"
NAP
011
020008
101CH2S
2"-NAP-011020008-101CH2S-P
Blind flange
-
-
P
25
NAPHTHA
Gas
-
3.00
110.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480048
1-1/2"
NAP
011
020009
101CH2S
011-A-0002-C/D
Reducer
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480048
2"
NAP
011
020009
101CH2S
2"-NAP-011020001-101CH2S-P
2"-NAP-011020009-101CH2S-P
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 7
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480048
1-1/2"
NAP
011
020009
101CH2S
011-A-0002-C/D
1-1/2"-NAP-011020009-101CH2SP
SA-JER-DS011-TRJR-480048
2"
NAP
011
020009
101CH2S
2"-NAP-011020001-101CH2S-P
2"-NAP-011020009-101CH2S-P
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480048
2"
NAP
011
020009
101CH2S
Reducer
2"-CLD-011020301-101CH2S-P
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 7
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480048
3/4"
NAP
011
020009
101CH2S
2"-NAP-011020009-101CH2S-P
3/4"-OLW-011020301-101CS1PN
SA-JER-DS011-TRJR-480048
1-1/2"
NAP
011
020009
101CH2S
2"-NAP-011020009-101CH2S-P
Blind flange
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480048
1-1/2"
NAP
011
020010
101CH2S
011-A-0002-E/F
Reducer
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 7
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 7
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 7
1-1/2"-NAP-011020010-101CH2S011-A-0002-E/F P 3/4"-OLW-011020303-101CS1P2"-NAP-011020010-101CH2S-P N
SA-JER-DS011-TRJR-480048
1-1/2"
NAP
011
020010
101CH2S
SA-JER-DS011-TRJR-480048
2"
NAP
011
020010
101CH2S
SA-JER-DS011-TRJR-480048
2"
NAP
011
020010
101CH2S
Reducer
2"-NAP-011020010-101CH2S-P
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480048
2"
NAP
011
020010
101CH2S
10"-NAP-011020001-101CH2S-P
2"-CLD-011020301-101CH2S-P
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480048
1-1/2"
NAP
011
020010
101CH2S
2"-NAP-011020010-101CH2S-P
Blind flange
-
-
P
25
NAPHTHA
Liquid/Gas Mixture
42.3
2.70
65.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 7
SA-JER-DS011-TRJR-480050
12"
NAP
011
021001
103CH2S
011-ZV-0009
SA-JER-DS011-TRJR-480051
-
-
N
-
TOTAL NAPHTHA
Liquid
650
1.80
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480051
12"
NAP
011
021001
103CH2S
SA-JER-DS011-TRJR-480050
12"-NAP-011021001-103CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
1.80
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
12"
NAP
011
021001
103CH2S
12"-NAP-011021001-103CH2S-N
Reducer
-
-
N
-
TOTAL NAPHTHA
Liquid
650
1.80
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
SA-JER-DS011-TRJR-480051
10"
NAP
011
021001
103CH2S
Reducer
011-G-0007-A
-
-
N
-
TOTAL NAPHTHA
Liquid
650
1.80
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
12"
NAP
011
021001
103CH2S
-
-
N
-
TOTAL NAPHTHA
Liquid
650
1.80
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480051
6"
NAP
011
021002
103CH2S
011-G-0007-A
Reducer
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
8"
NAP
011
021002
103CH2S
Reducer
8"-NAP-011021002-103CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
12"-NAP-011021001-103CH2S-N 12"-NAP-011021009-103CH2S-N
NOTE 6
Page 134 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
INSULATION (NOTE 2)
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
(NOTE 3)
(NOTE 4)
OPERATING CONDITIONS PRESS. (BARG)
TEMP. (ºC)
DESIGN CONDITIONS
ALTERNATE CONDITIONS PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
(ºC)
TEST CONDITIONS
MEDIUM (NOTE 5)
PRESS. (BARG)
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6)
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480140
8"
NAP
011
021002
103CH2S
SA-JER-DS011-TRJR-480051
SA-JER-DS111-TRJR-480043
-
-
N
-
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
8"
NAP
011
021002
103CH2S
8"-NAP-011021002-103CH2S-N
Reducer
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
6"
NAP
011
021002
103CH2S
Reducer
Reducer
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
8"
NAP
011
021002
103CH2S
Reducer
8"-NAP-011021002-103CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
8"
NAP
011
021002
103CH2S
8"-NAP-011021002-103CH2S-N
SA-JER-DS011-TRJR-480140
-
-
N
-
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
4"
NAP
011
021003
103CH2S
8"-NAP-011021002-103CH2S-N
SA-JER-DS011-TRJR-480046
-
-
N
-
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
4"
NAP
011
021003
103CH2S
SA-JER-DS011-TRJR-480051
Insul Brk
-
-
N
-
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Insul Brk
4"-NAP-011019001-101CH2S-P
-
-
P
25
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
P
25
650
7.30
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480046
4"
NAP
011
021003
103CH2S
SA-JER-DS011-TRJR-480046
3/4"
NAP
011
021003
103CH2S
4"-NAP-011021003-103CH2S-P
Blind flange
-
TOTAL NAPHTHA
Liquid
SA-JER-DS011-TRJR-480050
3"
NAP
011
021004
101CH2S
011-D-0005
3"-NAP-011021004-101CH2S-N
-
-
N
-
NAPHTHA
Gas
-
1.80
43.00
-
-
6.00
95.00
-
H
9.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
3"
NAP
011
021004
101CH2S
3"-FGS-011021301-101CS2P-S
Reducer
S
36.8
H
25
NAPHTHA
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
YES
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
1-1/2"
NAP
011
021004
101CH2S
Reducer
Insul Brk
S
36.8
H
25
NAPHTHA
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
YES
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
3"
NAP
011
021004
101CH2S
3"-NAP-011021004-101CH2S-S
Reducer
S
36.8
H
25
NAPHTHA
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
YES
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
2"
NAP
011
021004
101CH2S
Reducer
Reducer
S
36.8
H
25
NAPHTHA
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
YES
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
3"
NAP
011
021004
101CH2S
Reducer
Insul Brk
S
36.8
H
25
NAPHTHA
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
YES
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
3"
NAP
011
021004
101CH2S
Insul Brk
3"-NAP-011021004-101CH2S-N
-
-
N
-
NAPHTHA
Gas
-
1.80
43.00
-
-
6.00
95.00
-
H
9.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
3"
NAP
011
021004
101CH2S
3"-NAP-011021004-101CH2S-N
Reducer
-
-
N
-
NAPHTHA
Gas
-
1.80
43.00
-
-
6.00
95.00
-
H
9.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
2"
NAP
011
021004
101CH2S
Reducer
Reducer
-
-
N
-
NAPHTHA
Gas
-
1.80
43.00
-
-
6.00
95.00
-
H
9.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
3"
NAP
011
021004
101CH2S
Reducer
3"-LFL-011021302-101CH2F-N
-
-
N
-
NAPHTHA
Gas
-
1.80
43.00
-
-
6.00
95.00
-
H
9.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480050
10"
NAP
011
021005
101CH2S
011-D-0005
011-SP-0027
-
-
N
-
NAPHTHA
Gas
-
1.80
43.00
-
-
6.00
95.00
-
H
9.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480050
10"
NAP
011
021005
101CH2S
011-SP-0027
Reducer
-
-
N
-
NAPHTHA
Gas
-
1.80
43.00
-
-
6.00
95.00
-
H
9.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6 MAX. TEMPERATURE FOR OTHER CASE: 100ºC. MAX. TEMPERATURE DURING FIRE SCENARIO: 95ºC. NOTE 10, NOTE 6. MAX. TEMPERATURE FOR OTHER CASE: 100ºC. MAX. TEMPERATURE DURING FIRE SCENARIO: 95ºC. NOTE 10. MAX. TEMPERATURE FOR OTHER CASE: 100ºC. MAX. TEMPERATURE DURING FIRE SCENARIO: 95ºC. NOTE 10. MAX. TEMPERATURE FOR OTHER CASE: 100ºC. MAX. TEMPERATURE DURING FIRE SCENARIO: 95ºC. NOTE 10, NOTE 6. MAX. TEMPERATURE FOR OTHER CASE: 100ºC. MAX. TEMPERATURE DURING FIRE SCENARIO: 95ºC. NOTE 10. MAX. TEMPERATURE FOR OTHER CASE: 100ºC. MAX. TEMPERATURE DURING FIRE SCENARIO: 95ºC. NOTE 10. MAX. TEMPERATURE FOR OTHER CASE: 100ºC. MAX. TEMPERATURE DURING FIRE SCENARIO: 95ºC. NOTE 10. MAX. TEMPERATURE FOR OTHER CASE: 100ºC. MAX. TEMPERATURE DURING FIRE SCENARIO: 95ºC. NOTE 10.
SA-JER-DS011-TRJR-480050
6"
NAP
011
021005
101CH2S
Reducer
011-PZV-0014
-
-
N
-
NAPHTHA
Gas
-
1.80
43.00
-
-
6.00
95.00
-
H
9.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480050
10"
NAP
011
021005
101CH2S
10"-NAP-011021005-101CH2S-N
011-SP-0027
-
-
N
-
NAPHTHA
Gas
-
1.80
43.00
-
-
6.00
95.00
-
H
9.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480050
10"
NAP
011
021005
101CH2S
011-SP-0027
Reducer
-
-
N
-
NAPHTHA
Gas
-
1.80
43.00
-
-
6.00
95.00
-
H
9.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480050
6"
NAP
011
021005
101CH2S
Reducer
011-PZV-0015
-
-
N
-
NAPHTHA
Gas
-
1.80
43.00
-
-
6.00
95.00
-
H
9.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480050
3/4"
NAP
011
021005
101CH2S
10"-NAP-011021005-101CH2S-N 3/4"-LFL-011021308-101CH2F-N
-
-
N
-
NAPHTHA
Gas
-
1.80
43.00
-
-
6.00
95.00
-
H
9.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480050
3/4"
NAP
011
021005
101CH2S
10"-NAP-011021005-101CH2S-N 3/4"-LFL-011021308-101CH2F-N
-
-
N
-
NAPHTHA
Gas
-
1.80
43.00
-
-
6.00
95.00
-
H
9.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480140
4"
NAP
011
021006
103CH2S
8"-NAP-011098003-103CH2S-N
SA-JER-DS011-TRJR-480022
-
-
N
-
TOTAL NAPHTHA
Liquid
675
7.30
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480022
4"
NAP
011
021006
103CH2S
SA-JER-DS011-TRJR-480140
4"-NAP-011012021-103CH2S-P
-
-
N
-
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
12"
NAP
011
021009
103CH2S
12"-NAP-011021001-103CH2S-N
Reducer
-
-
N
-
TOTAL NAPHTHA
Liquid
650
1.80
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
10"
NAP
011
021009
103CH2S
Reducer
011-G-0007-B
-
-
N
-
TOTAL NAPHTHA
Liquid
650
1.80
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
6"
NAP
011
021010
103CH2S
011-G-0007-B
Reducer
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
8"
NAP
011
021010
103CH2S
Reducer
8"-NAP-011021010-103CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
8"
NAP
011
021010
103CH2S
8"-NAP-011021010-103CH2S-N
8"-NAP-011021002-103CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
3/4"
NAP
011
021011
103CH2S
8"-NAP-011021002-103CH2S-N
Reducer
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
2"
NAP
011
021011
103CH2S
Reducer
2"-CLD-011021304-101CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
3/4"
NAP
011
021011
103CH2S
8"-NAP-011021002-103CH2S-N
3/4"-NAP-011021011-103CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
SA-JER-DS011-TRJR-480051
3/4"
NAP
011
021013
103CH2S
8"-NAP-011021002-103CH2S-N
011-SC-0007
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6 NOTE 6 THIS LINE IS ALREADY DRAW IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. NOTE 6. THIS LINE IS ALREADY DRAW IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. NOTE 6.
SA-JER-DS011-TRJR-480275
4"
NAP
011
021013
103CH2S
Reducer
Reducer
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
170.00
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
SA-JER-DS011-TRJR-480275
3/4"
NAP
011
021013
103CH2S
Reducer
3/4"-NAP-011021014-103CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
170.00
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
SA-JER-DS011-TRJR-480275
3/4"
NAP
011
021013
103CH2S 3/4"-NAP-011021013-103CH2S-N
Reducer
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
170.00
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/2"
NAP
011
021013
103CH2S
Reducer
Reducer
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
170.00
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/4"
NAP
011
021013
103CH2S
Reducer
SAMPLE CYLINDER
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
170.00
28.00
95.00
-
-
-
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480051
3/4"
NAP
011
021014
103CH2S
011-SC-0007
8"-NAP-011021002-103CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480275
3/4"
NAP
011
021014
103CH2S 3/4"-NAP-011021014-103CH2S-N
Reducer
-
-
N
-
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
170.00
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/2"
NAP
011
021014
103CH2S
Reducer
Reducer
-
-
N
-
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
170.00
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
NAP
011
021014
103CH2S
Reducer
Reducer
-
-
N
-
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
170.00
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
2"
NAP
011
021014
103CH2S
Reducer
2"-CLD-011200305-101CH2S-P
-
-
N
-
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
170.00
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
SA-JER-DS011-TRJR-480275
1/4"
NAP
011
021014
103CH2S
SAMPLE CYLINDER
Reducer
-
-
N
-
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
170.00
28.00
95.00
-
-
-
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/2"
NAP
011
021014
103CH2S
Reducer
1/2"-NAP-011021014-103CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
170.00
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6.
NOTE 6.
SA-JER-DS011-TRJR-480051
2"
NAP
011
021015
103CH2S
10"-NAP-011021001-103CH2S-N
2"-NAP-011021015-103CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
3/4"
NAP
011
021015
103CH2S
011-G-0007-A
2"-NAP-011021015-103CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
3/4"
NAP
011
021015
103CH2S
12"-NAP-011021001-103CH2S-N
2"-NAP-011021015-103CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
2"
NAP
011
021015
103CH2S
8"-NAP-011021002-103CH2S-N
2"-CLD-011021302-101CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
3/4"
NAP
011
021015
103CH2S
011-G-0007-A
2"-NAP-011021015-103CH2S-N
-
-
N
-
TOTAL NAPHTHA
Gas
-
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
1/2"
NAP
011
021015
103CH2S
011-PI-0042
2"-NAP-011021015-103CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
2"
NAP
011
021016
103CH2S
10"-NAP-011021009-103CH2S-N
2"-NAP-011021016-103CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
3/4"
NAP
011
021016
103CH2S
011-G-0007-B
2"-NAP-011021016-103CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
3/4"
NAP
011
021016
103CH2S
12"-NAP-011021009-103CH2S-N
2"-NAP-011021016-103CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
2"
NAP
011
021016
103CH2S
8"-NAP-011021010-103CH2S-N
2"-CLD-011021303-101CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
3/4"
NAP
011
021016
103CH2S
011-G-0007-B
2"-NAP-011021016-103CH2S-N
-
-
N
-
TOTAL NAPHTHA
Gas
-
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480051
1/2"
NAP
011
021016
103CH2S
011-PI-0043
2"-NAP-011021016-103CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
18.50
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
3/4"
NAP
011
021018
101CH2S
011-LG-0029
3/4"-LFL-011021303-101CH2F-N
-
-
N
-
NAPHTHA
Gas
-
1.80
43.00
-
-
6.00
95.00
-
H
9.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
3/4"
NAP
011
021019
101CH2S
011-LDG-0031
3/4"-LFL-011021304-101CH2F-N
-
-
N
-
NAPHTHA
Gas
-
1.80
43.00
-
-
6.00
95.00
-
H
9.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
12"
NAP
011
021022
101CH2S
011-D-0005
011-ZV-0009
-
-
N
-
TOTAL NAPHTHA
Liquid
650
1.80
43.00
-
-
6.60
95.00
-
H
9.90
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
2"
NAP
011
021023
101CH2S
UC
011-D-0005
-
-
P
25
NAPHTHA
Liquid
650
1.80
43.00
-
-
6.00
95.00
-
H
9.00
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: 7 BARG+FV@290ºC.
SA-JER-DS011-TRJR-480050
3/4"
NAP
011
021023
101CH2S
2"-NAP-011021023-101CH2S-P
Plug
-
-
P
25
NAPHTHA
Liquid
650
1.80
43.00
-
-
6.00
95.00
-
H
9.00
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: 7 BARG+FV@290ºC.
SA-JER-DS011-TRJR-480050
3/4"
NAP
011
021024
101CH2S
3"-NAP-011021004-101CH2S-S
3/4"-LFL-011021305-101CH2F-N
S
36.8
H
25
NAPHTHA
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
YES
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
3/4"
NAP
011
021024
101CH2S 3/4"-NAP-011021024-101CH2S-S
Blind flange
S
36.8
H
25
NAPHTHA
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
YES
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
3/4"
NAP
011
021024
101CH2S
3"-NAP-011021004-101CH2S-S
3/4"-NAP-011021024-101CH2S-S
S
36.8
H
25
NAPHTHA
Gas
-
3.50
52.30
-
-
8.50
155.00
-
H
12.75
NFS
YES
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
3/4"
NAP
011
021025
101CH2S
3"-NAP-011021004-101CH2S-N
3/4"-LFL-011021306-101CH2F-N
-
-
N
-
NAPHTHA
Gas
-
1.80
43.00
-
-
6.00
95.00
-
H
9.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480050
3/4"
NAP
011
021025
101CH2S
3"-NAP-011021004-101CH2S-N
3/4"-NAP-011021025-101CH2S-N
-
-
N
-
NAPHTHA
Gas
-
1.80
43.00
-
-
6.00
95.00
-
H
9.00
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
if insulated M or Q SA-JER-DS011-TRJR-480050
-
NAP
011
021601
101CH2S
011-D-0005
TRIM
-
-
N
-
-
-
-
1.80
43.00
-
-
6.00
95.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480113
-
NAP
011
044601
101CH2S
011-D-0006
TRIM
-
-
P
-
-
-
-
0.30
65.00
-
-
5.00
110.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-380001
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
Page 135 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
011
044601
101CH2S
011-D-0006
Blind flange
-
-
P
25
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
-
-
0.30
65.00
-
-
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
-
H
7.50
NFS
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7) if insulated M or Q
SA-JER-DS011-TRJR-480113
2"
NAP
-
5.00
110.00
YES
if NOT insulated B or Q
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C
SA-JER-DS011-TRJR-480135
3"
NAP
011
098001
103CH2S
IP-1305-L
Reducer
-
-
P
25
HEAVY NAPHTHA
Liquid
651
5.00
70.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480135
3/4"
NAP
011
098001
103CH2S
011-PI-0173
3"-NAP-011098001-103CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
651
5.00
70.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480135
4"
NAP
011
098001
103CH2S
Reducer
Reducer
-
-
P
25
HEAVY NAPHTHA
Liquid
651
5.00
70.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
3"
NAP
011
098001
103CH2S
SA-JER-DS011-TRJR-480135
16"-DIE-011018003-101CS1P-H
-
-
P
25
HEAVY NAPHTHA
Liquid
651
5.00
70.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480043
3/4"
NAP
011
098001
103CH2S
3"-NAP-011098001-103CH2S-P
Blind flange
-
-
P
25
HEAVY NAPHTHA
Liquid
651
5.00
70.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480135
3"
NAP
011
098001
103CH2S
Reducer
SA-JER-DS011-TRJR-480043
-
-
P
25
HEAVY NAPHTHA
Liquid
651
5.00
70.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480135
1/2"
NAP
011
098001
103CH2S
011-FE-0017
011-FT-0017
-
-
P
25
HEAVY NAPHTHA
Liquid
651
5.00
70.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480135
1/2"
NAP
011
098001
103CH2S
011-FE-0017
011-FT-0017
-
-
P
25
HEAVY NAPHTHA
Liquid
651
5.00
70.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480135
3"
NAP
011
098002
103CH2S
3"-NAP-011098001-103CH2S-P
SA-JER-DS011-TRJR-480020
-
-
P
25
HEAVY NAPHTHA
Liquid
651
5.00
70.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480020
3"
NAP
011
098002
103CH2S
SA-JER-DS011-TRJR-480135
3"-CRU-011010005-101CH2S-H
-
-
P
25
HEAVY NAPHTHA
Liquid
651
5.00
70.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480020
3/4"
NAP
011
098002
103CH2S
3"-NAP-011098002-103CH2S-P
Blind flange
-
-
P
25
HEAVY NAPHTHA
Liquid
651
5.00
70.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
8"
NAP
011
098003
103CH2S
8"-NAP-011021002-103CH2S-N
SA-JER-DS011-TRJR-480136
-
-
N
-
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
8"
NAP
011
098003
103CH2S
SA-JER-DS011-TRJR-480140
8"-SLP-011099001-103CS1P-S
-
-
N
-
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
3/4"
NAP
011
098004
103CH2S
8"-NAP-011021002-103CH2S-N
Reducer
-
-
N
-
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480140
2"
NAP
011
098004
103CH2S
Reducer
2"-CLD-011098312-101CH2S-N
-
-
N
-
TOTAL NAPHTHA
Liquid
650
7.30
43.00
-
-
28.00
95.00
-
H
42.00
NFS
YES
A or Q
Y
Y
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480135
3/4"
NAP
011
098005
103CH2S
3"-NAP-011098001-103CH2S-P
SA-JER-DS011-TRJR-480274
3/4"
NAP
011
098005
103CH2S 3/4"-NPH-011098001-103CH2S-P
SA-JER-DS011-TRJR-480135
3/4"
NAP
011
098007
103CH2S
SA-JER-DS011-TRJR-480135
3/4"
NAP
011
098007
103CH2S 3/4"-NAP-011098007-103CH2S-P
SA-JER-DS011-TRJR-480135
2"
NAP
011
098007
103CH2S
SA-JER-DS011-TRJR-480135
3/4"
NAP
011
098007
SA-JER-DS011-TRJR-480136
8"
NAP
011
SA-JER-DS011-TRJR-480274
3/4"
NAP
SA-JER-DS011-TRJR-480274
4"
NAP
SA-JER-DS011-TRJR-480274
3/4"
SA-JER-DS011-TRJR-480274
011-SC-0039
-
-
P
25
HEAVY NAPHTHA
Liquid
651
5.00
70.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SAMPLE COOLER
-
-
P
25
HEAVY NAPHTHA
Liquid
651
5.00
70.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Reducer
-
-
P
25
HEAVY NAPHTHA
Liquid
651
5.00
70.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Blind flange
-
-
P
25
HEAVY NAPHTHA
Liquid
651
5.00
70.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Reducer
2"-CLD-011098313-101CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
651
5.00
70.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
103CH2S
3"-NAP-011098001-103CH2S-P
3/4"-NAP-011098007-103CH2S-P
-
-
P
25
HEAVY NAPHTHA
Liquid
651
5.00
70.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
098008
103CS1P
8"-NAP-011098003-103CH2S-N
8"-HFO-011098012-103CS1P-S
S
41
H
40
TOTAL NAPHTHA
Liquid
846
6.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
Y
N
N
N
N
-
NOTE 6
011
200001
103CH2S
SAMPLE COOLER
Reducer
-
-
N
-
HEAVY NAPHTHA
Liquid
651
5.00
60.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
011
200001
103CH2S
Reducer
Reducer
-
-
N
-
HEAVY NAPHTHA
Liquid
651
5.00
60.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
NAP
011
200001
103CH2S
Reducer
3/4"-LFL-011200309-101CH2F-N
-
-
N
-
HEAVY NAPHTHA
Liquid
651
5.00
60.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
1/2"
NAP
011
200001
103CH2S 3/4"-NAP-011200001-103CH2S-N
Reducer
-
-
N
-
HEAVY NAPHTHA
Liquid
651
5.00
60.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
1/4"
NAP
011
200001
103CH2S
Reducer
SAMPLE CYLINDER
-
-
N
-
HEAVY NAPHTHA
Liquid
651
5.00
60.00
-
-
18.40
120.00
-
-
-
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
1/4"
NAP
011
200001
103CH2S
SAMPLE CYLINDER
Reducer
-
-
N
-
HEAVY NAPHTHA
Liquid
651
5.00
60.00
-
-
18.40
120.00
-
-
-
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
1/2"
NAP
011
200001
103CH2S
Reducer
3/4"-NAP-011200001-103CH2S-N
-
-
N
-
HEAVY NAPHTHA
Liquid
651
5.00
60.00
-
-
18.40
120.00
-
H
27.60
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
NAP
011
200002
101CH2S
SAMPLE COOLER
Reducer
-
-
P
25
NAPHTHA
Gas
-
3.00
60.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
4"
NAP
011
200002
101CH2S
Reducer
Reducer
-
-
P
25
NAPHTHA
Gas
-
3.00
60.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
NAP
011
200002
101CH2S
Reducer
3/4"-LFL-011200304-101CH2F-N
-
-
P
25
NAPHTHA
Gas
-
3.00
60.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
3/4"
NAP
011
200002
101CH2S 3/4"-NAP-011200002-101CH2S-P
Plug
-
-
P
25
NAPHTHA
Gas
-
3.00
60.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
1/2"
NAP
011
200002
101CH2S 3/4"-NAP-011200002-101CH2S-P
Reducer
-
-
P
25
NAPHTHA
Gas
-
3.00
60.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
1/4"
NAP
011
200002
101CH2S
Reducer
SAMPLE CYLINDER
-
-
P
25
NAPHTHA
Gas
-
3.00
60.00
-
-
5.50
140.00
-
-
-
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
1/4"
NAP
011
200002
101CH2S
SAMPLE CYLINDER
Reducer
-
-
P
25
NAPHTHA
Gas
-
3.00
60.00
-
-
5.50
140.00
-
-
-
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
1/2"
NAP
011
200002
101CH2S
Reducer
3/4"-NAP-011200002-101CH2S-P
-
-
P
25
NAPHTHA
Gas
-
3.00
60.00
-
-
5.50
140.00
-
H
8.25
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480275
3/4"
NAP
011
200003
101CH2S
SAMPLE COOLER
Reducer
-
-
N
-
NAPHTHA
Liquid
680
7.50
60.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
4"
NAP
011
200003
101CH2S
Reducer
Reducer
-
-
N
-
NAPHTHA
Liquid
680
7.50
60.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
NAP
011
200003
101CH2S
Reducer
3/4"-NAP-011019020-101CH2S-P
-
-
N
-
NAPHTHA
Liquid
680
7.50
60.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
3/4"
NAP
011
200003
101CH2S 3/4"-NAP-011200003-101CH2S-N
Reducer
-
-
N
-
NAPHTHA
Liquid
680
7.50
60.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/2"
NAP
011
200003
101CH2S
Reducer
Reducer
-
-
N
-
NAPHTHA
Liquid
680
7.50
60.00
-
-
13.00
100.00
-
H
19.50
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480275
1/4"
NAP
011
200003
101CH2S
Reducer
SAMPLE CYLINDER
-
-
N
-
NAPHTHA
Liquid
680
7.50
60.00
-
-
13.00
100.00
-
-
-
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480002
3/4"
OLW
011
001303
101CS1P 3/4"-CRU-011001012-106CS1P-N
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480002
3/4"
OLW
011
001304
101CS1P 3/4"-CRU-011001013-106CS1P-N
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480011
3/4"
OLW
011
006301
101CS1P 3/4"-CLD-011006303-103CH2S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480011
1"
OLW
011
006306
101CS1P
1"-CLD-011006309-103CS4P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480011
3/4"
OLW
011
006307
101CS1P
011-TZV-0090
Reducer
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480011
1"
OLW
011
006307
101CS1P
Reducer
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480011
3/4"
OLW
011
006307
101CS1P
011-TZV-0091
Reducer
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
Reducer
1"-OLW-011006307-101CS1P-N
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
-
N
-
1000
0.00
27.00
-
-
0.00
60.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
3"-NAP-011098001-103CH2S-P
SA-JER-DS011-TRJR-480011
1"
OLW
011
006307
101CS1P
SA-JER-DS011-TRJR-480011
3/4"
OLW
011
006307
101CS1P
011-TZV-0092
Reducer
-
WATER
Liquid
SA-JER-DS011-TRJR-480011
1"
OLW
011
006307
101CS1P
Reducer
1"-OLW-011006307-101CS1P-N
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480012
3/4"
OLW
011
007301
101CS1P 3/4"-CLD-011007305-103CH2S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480012
1"
OLW
011
007302
101CS1P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480013
3/4"
OLW
011
007303
101CS1P 3/4"-BRN-011007006-106CS2P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480013
3/4"
OLW
011
007304
101CS1P 3/4"-BRN-011007007-106CS2P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480012
3/4"
OLW
011
007305
101CS1P
Reducer
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
1"-CLD-011007309-103CS4P-P
011-TZV-0095
SA-JER-DS011-TRJR-480012
1"
OLW
011
007305
101CS1P
Reducer
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480012
3/4"
OLW
011
007305
101CS1P
011-TZV-0094
Reducer
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480012
1"
OLW
011
007305
101CS1P
Reducer
1"-OLW-011007305-101CS1P-N
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480012
3/4"
OLW
011
007305
101CS1P
011-TZV-0093
Reducer
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480012
1"
OLW
011
007305
101CS1P
Reducer
1"-OLW-011007305-101CS1P-N
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480015
3/4"
OLW
011
008301
101CS1P 3/4"-CRU-011008008-103CS1P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480015
3/4"
OLW
011
008302
101CS1P 3/4"-CRU-011008009-103CS1P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480021
3/4"
OLW
011
011301
101CS1P 3/4"-CRU-011011008-106CS1P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480021
3/4"
OLW
011
011302
101CS1P 3/4"-CRU-011011009-106CS1P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480020
6"
OLW
011
011303
101CS1P
6"-CRU-011011015-101CS1P-H
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480142
1"
OLW
011
011304
101CS1P
011-Y-0001
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480022
3/4"
OLW
011
012301
101CS1P 3/4"-NAP-011012008-101CH2S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480022
3/4"
OLW
011
012302
101CS1P 3/4"-NAP-011012009-101CH2S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480023
3/4"
OLW
011
012303
101CS1P
3/4"-AWS-011012004-101CH2SP
SA-JER-DS011-TRJR-480023
2"
OLW
011
012305
101CS1P
2"-AWS-011012006-101CH2S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480141
3/4"
OLW
011
013301
101CS1P 3/4"-HFO-011013009-103SD0P-S
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480042
1"
OLW
011
017002
101CS1P
011-Y-0003
OLW
-
-
P
25
WATER
Liquid
1000
0.00
27.00
-
-
0.00
100.00
-
Visual Test
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480042
1"
OLW
011
017302
101CS1P
011-Y-0004
OLW
-
-
P
25
WATER
Liquid
1000
0.00
27.00
-
-
0.00
100.00
-
Visual Test
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480044
6"
OLW
011
018301
101CS1P
6"-HFO-011018105-103CL4P-S
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480044
1"
OLW
011
018302
101CS1P
1"-CRU-011018004-101CL4P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480045
3/4"
OLW
011
019301
101CS1P 3/4"-NAP-011019009-101CH2S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480046
3/4"
OLW
011
019302
101CS1P
3/4"-AWS-011019004-101CH2SP
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480047
3/4"
OLW
011
019303
101CS1P 3/4"-NAP-011019016-101CH2S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480047
3/4"
OLW
011
019304
101CS1P 3/4"-NAP-011019017-101CH2S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480046
4"
OLW
011
019305
101CS1P
4"-AWS-011019009-101CH2S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480045
3/4"
OLW
011
019306
101CS1P 3/4"-NAP-011019035-101CH2S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480048
3/4"
OLW
011
020301
101CS1P 3/4"-NAP-011020009-101CH2S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480048
3/4"
OLW
011
020302
101CS1P
2"-NAP-011020003-101CH2S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480048
3/4"
OLW
011
020303
101CS1P
2"-NAP-011020010-101CH2S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
-
Page 136 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DENSITY (kg/m3)
DOC. No.
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480050
3/4"
OLW
011
021301
101CS1P
3/4"-AWS-011021004-101CH2SN
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480051
3/4"
OLW
011
021302
101CS1P 3/4"-NAP-011021015-103CH2S-N
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480051
3/4"
OLW
011
021303
101CS1P 3/4"-NAP-011021016-103CH2S-N
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
-
N
-
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480050
4"
OLW
011
021304
101CS1P
SA-JER-DS011-TRJR-480052
3/4"
OLW
011
022001
101CS1P
3/4"-JET-011022011-103CS1P-P
OLW
-
WATER
Liquid
SA-JER-DS011-TRJR-480053
3/4"
OLW
011
022302
101CS1P
3/4"-JET-011022018-103CS1P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480053
3/4"
OLW
011
022303
101CS1P
3/4"-JET-011022019-103CS1P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
2"
OLW
011
022304
101CS1P
2"-JET-011022020-101CS1P-H
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480052
4"
OLW
011
022305
101CS1P
4"-JET-011022021-101CS1P-H
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480055
3/4"
OLW
011
023301
101CS1P
3/4"-DIE-011023012-103CS2P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480055
3/4"
OLW
011
023302
101CS1P
3/4"-DIE-011023013-103CS2P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480054
3/4"
OLW
011
023303
101CS1P
3/4"-DIE-011023007-101CS2P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480054
3"
OLW
011
023304
101CS1P
3"-DIE-011023011-101CS2P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480054
1"
OLW
011
023305
101CS1P
011-Y-0005
OLW
-
-
P
25
WATER
Liquid
1000
0.00
27.00
-
-
0.00
100.00
-
Visual Test
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480056
3/4"
OLW
011
024301
101CS1P
3/4"-HFO-011024014-103CL2P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
4"-AWS-011021006-101CH2S-N
SA-JER-DS011-TRJR-480056
3"
OLW
011
024302
101CS1P
3"-HFO-011024010-101CL2P-H
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480057
3/4"
OLW
011
024303
101CS1P
3/4"-HFO-011024008-103CL2P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480057
3/4"
OLW
011
024304
101CS1P
3/4"-HFO-011024009-103CL2P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480056
1"
OLW
011
024306
101CS1P
011-Y-0006
OLW
-
-
P
25
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
-
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480061
3/4"
OLW
011
025302
101CS1P
1-1/2"-HFO-011025012-103CS1PP
SA-JER-DS011-TRJR-480063
3/4"
OLW
011
026301
101CS1P
3/4"-JET-011026006-101CS1P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480063
3/4"
OLW
011
026302
101CS1P
3/4"-JET-011026007-101CS1P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480064
3/4"
OLW
011
026303
101CS1P
3/4"-DIE-011026006-103CS2P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480064
3/4"
OLW
011
026304
101CS1P
3/4"-DIE-011026007-103CS2P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480065
3/4"
OLW
011
027001
101CS1P
3/4"-HFO-011027006-103CL2P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480065
3/4"
OLW
011
027002
101CS1P
3/4"-HFO-011027007-103CL2P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480066
1"
OLW
011
027303
101CS1P
1"-HFO-011027107-103CL4P-S
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480066
1"
OLW
011
027304
101CS1P
1"-HFO-011027108-103CL4P-S
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480081
6"
OLW
011
030301
101CS1P
6"-HFO-011030102-101CL4P-S
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480081
1"
OLW
011
030302
101CS1P
3/4"-HFO-011030103-101CL4P-S
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480081
3/4"
OLW
011
030303
101CS1P 3/4"-HFO-011030107-101SD0P-S
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480081
3/4"
OLW
011
030305
101CS1P
3/4"-HFO-011030108-101CM2PS
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480086
3"
OLW
011
033022
101CS1P
3"-AWS-011033022-101CH2S-N
3"-OLW-011033302-101CS1P-N
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480086
2"
OLW
011
033301
101CS1P
2"-AWS-011033020-101CH2S-N
3"-OLW-011033302-101CS1P-N
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480086
3"
OLW
011
033302
101CS1P
Reducer
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480086
2"
OLW
011
033303
101CS1P
2"-PRO-011033018-101CH2S-N
Reducer
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480086
3/4"
OLW
011
033304
101CS1P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480086
3/4"
OLW
011
033305
101CS1P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480088
3/4"
OLW
011
033306
101CS1P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480088
3/4"
OLW
011
033307
101CS1P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480087
3/4"
OLW
011
033308
101CS1P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480087
3/4"
OLW
011
033309
101CS1P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480086
3/4"
OLW
011
033310
101CS1P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480088
2"
OLW
011
033311
101CS1P
011-G-0019-A
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480088
2"
OLW
011
033312
101CS1P
011-G-0019-B
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480089
2"
OLW
011
034301
101CS1P
2"-AWS-011034007-101CH2S-N
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480089
3/4"
OLW
011
034301
101CS1P
2"-OLW-011034301-101CS1P-N
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480090
3/4"
OLW
011
034303
101CS1P
End
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480090
2"
OLW
011
034305
101CS1P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480262
2"
OLW
011
035301
101CS1P
Closed spectacle blank
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
55.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480262
2"
OLW
011
035302
101CS1P
011-D-0028
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
55.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480262
3/4"
OLW
011
035303
101CS1P 3/4"-PRO-011035422-101SD0P-N
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480262
3/4"
OLW
011
035309
101CS1P 3/4"-PRO-011035421-101SD0P-P
FDP
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
55.00
-
H
0.00
ASME N/A
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480093
1"
OLW
011
036301
101CS1P
1"-AWS-011036007-101CH4S-N
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480093
2"
OLW
011
036302
101CS1P
2"-AWS-011036006-101CH4S-N
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480095
3/4"
OLW
011
036303
101CS1P
3/4"-AMI-011036016-103CH2S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480095
3/4"
OLW
011
036304
101CS1P
3/4"-AMI-011036017-103CH2S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480094
3"
OLW
011
036307
101CS1P
3"-AMI-011036022-101CH4S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480094
3/4"
OLW
011
036308
101CS1P
3/4"-AMI-011036009-101CH4S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480095
2"
OLW
011
036309
101CS1P
011-G-0023-A
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480095
2"
OLW
011
036310
101CS1P
011-G-0023-B
OLW
-
-
P
25
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480096
3/4"
OLW
011
037301
101CS1P
3/4"-DIE-011037011-103CS1P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480096
3/4"
OLW
011
037302
101CS1P
3/4"-DIE-011037012-103CS1P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480097
3/4"
OLW
011
037303
101CS1P
3/4"-DIE-011037023-103CS1P-N
OlW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480099
3/4"
OLW
011
038301
101CS1P
3/4"-HFO-011038012-103CL2P-S
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
170.00
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480099
3/4"
OLW
011
038302
101CS1P
3/4"-HFO-011038013-103CL2P-S
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
170.00
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480101
3/4"
OLW
011
039001
101CS1P
3/4"-HFO-011039011-103CL2P-S
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480101
3/4"
OLW
011
039002
101CS1P
3/4"-HFO-011039012-103CL2P-S
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480102
3/4"
OLW
011
039003
101CS1P 3/4"-HFO-011039015-103SD0P-S
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480103
1"
OLW
011
039004
101CS1P
3/4"-HFO-011039107-103CL4P-S
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480103
1"
OLW
011
039005
101CS1P
3/4"-HFO-011039108-103CL4P-S
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
3/4"-PRO-011033010-101CH2SN 3/4"-AWS-011033013-101CH2SN 3/4"-AWS-011033015-106CH2SN 3/4"-AWS-011033016-106CH2SN 3/4"-PRO-011033013-103CH2SN 3/4"-PRO-011033014-103CH2SN 3/4"-AWS-011033012-101CH2SN
3/4"-AWS-011034005-101CH2SN 3/4"-AWS-011034008-101CH2SN 2"-AWS-011034009-101CH2S-N
3/4"-BFW-011040003-101CS1PH 3/4"-BFW-011040004-101CS1PH
SA-JER-DS011-TRJR-480104
3/4"
OLW
011
040302
101CS1P
SA-JER-DS011-TRJR-480104
3/4"
OLW
011
040303
101CS1P
SA-JER-DS011-TRJR-480105
2"
OLW
011
040305
101CS1P
2"-BDH-011040004-101CS1P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
2"
OLW
011
040306
101CS1P
2"-BDH-011040005-101CS1P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
1"
OLW
011
040307
101CS1P
011-Y-0008
OLW
-
-
P
25
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
-
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
3/4"-BFW-011040007-101CS1PH 3/4"-BFW-011040008-101CS1PH
SA-JER-DS011-TRJR-480104
3/4"
OLW
011
040308
101CS1P
SA-JER-DS011-TRJR-480104
3/4"
OLW
011
040309
101CS1P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480106
1"
OLW
011
041301
101CS1P
011-Y-0009
OLW
-
-
P
25
WATER
Liquid
1000
0.00
27.00
-
-
0.00
100.00
-
Visual Test
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480106
1"
OLW
011
041302
101CS1P
011-Y-0010
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480109
1"
OLW
011
042301
101CS1P 3/4"-BRN-011042006-101CS4P-N
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480108
1"
OLW
011
042302
101CS1P
1"-BRN-011042008-101CS4P-P
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
2"
OLW
011
043301
101CS1P
2"-PRW-011043017-101CS2P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
2"
OLW
011
043302
101CS1P
2"-PRW-011043008-101CS2P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480111
1-1/2"
OLW
011
043303
101CS1P
SA-JER-DS011-TRJR-480111
1-1/2"
OLW
011
043304
101CS1P
SA-JER-DS011-TRJR-380001
1-1/2"-PRW-011043015106CS2P-P 1-1/2"-PRW-011043014106CS2P-P
Page 137 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM 3/4"-AWS-011044008-106CH2SP 3/4"-AWS-011044009-106CH2SP
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
OLW
-
-
N
-
OLW
-
-
N
-
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
WATER
Liquid
1000
0.00
27.00
-
-
0.00
WATER
Liquid
1000
0.00
27.00
-
-
0.00
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
(NOTE 7)
SA-JER-DS011-TRJR-480114
3/4"
OLW
011
044302
101CS1P
SA-JER-DS011-TRJR-480114
3/4"
OLW
011
044303
101CS1P
SA-JER-DS011-TRJR-480113
2"
OLW
011
044304
101CS1P
2"-AWS-011044012-101CH2S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480114
2"
OLW
011
044305
101CS1P
3
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480114
2"
OLW
011
044306
101CS1P
3
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480121
2"
OLW
011
051301
101CS1P
FLUE GAS DUCT
Insul Brk
-
-
P
25
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
H
0.00
ASME N/A
By Vendor
By Vendor
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480121
2"
OLW
011
051301
101CS1P
Insul Brk
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Vendor
By Vendor
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480122
2"
OLW
011
052301
101CS1P
2"-PRW-011052017-101CS2P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480122
2"
OLW
011
052302
101CS1P
2"-PRW-011052009-101CS2P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
2"
OLW
011
052303
101CS1P
2"-PRW-011052015-101CS2P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
2"
OLW
011
052304
101CS1P
2"-PRW-011052016-101CS2P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
2"
OLW
011
052306
101CS1P
2"-PRW-011052011-101CS2P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
2"
OLW
011
071301
101CS1P
2"-LPC-011071004-101CS1P-H
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
2"
OLW
011
071302
101CS1P
2"-LPC-011071005-101CS1P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
2"
OLW
011
071303
101CS1P
2"-LPC-011071006-101CS1P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
2"
OLW
011
071304
101CS1P
2"-LPC-011071001-101CS1P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480201
2"
OLW
011
071305
101CS1P
2"-LPC-011071007-101CS1P-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
6"
OLW
011
071306
101CS1P
HEADER
OLW
-
-
P
25
OILY WATER
Liquid
958
0.00
27.00
-
-
0.00
128.00
-
Visual Test
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480202
4"
OLW
011
071307
101CS1P
HEADER
OLW
-
-
P
25
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
128.00
-
Visual Test
0.00
ASME N/A
By Code
M
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
3/4"
OLW
011
075301
101CS1P 3/4"-FGS-011075305-101CS2P-S
2"-OLW-011075302-101CS1P-N
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
101CS1P
2"-FGS-011075307-101CS2P-N
OLW
-
WATER
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480219
4"
OLW
011
076301
101CS1P
4"-SLP-011076010-101CH2S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480219
3/4"
OLW
011
076302
101CS1P
3/4"-SLP-011076009-101CH2S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
170.00
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480219
3/4"
OLW
011
076303
101CS1P
3/4"-SLP-011076007-103CH2S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480219
3/4"
OLW
011
076304
101CS1P
3/4"-SLP-011076008-103CH2S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480233
2"
OLW
011
079301
101CS1P
2"-AMD-011079318-101CH2S-P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480233
3/4"
OLW
011
079302
101CS1P
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480233
3/4"
OLW
011
079303
101CS1P
TO GRADE
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480233
3/4"
OLW
011
079304
101CS1P
SA-JER-DS011-TRJR-480135
3/4"
OLW
011
098301
101CS1P
SA-JER-DS011-TRJR-480250
2"
OLW
011
171301
101CS1P
SA-JER-DS011-TRJR-480250
2"
OLW
011
171302
SA-JER-DS011-TRJR-480250
2"
OLW
011
SA-JER-DS011-TRJR-480250
2"
OLW
SA-JER-DS011-TRJR-480244
2"
SA-JER-DS011-TRJR-480244 SA-JER-DS011-TRJR-480244
SA-JER-DS011-TRJR-480214
2"
OLW
011
075302
3/4"-AMD-011079306-103CH2SP 3/4"-AMD-011079007-101CH2SP 3/4"-AMD-011079309-103CH2SP 3/4"-STW-011098003-101CS2PN
-
-
N
Liquid
1000
0.00
27.00
-
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
TO GROUND
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
011-G-0011-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
101CS1P
011-G-0011-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
171303
101CS1P
011-G-0013-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
011
171304
101CS1P
011-G-0013-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
OLW
011
171305
101CS1P
011-G-0001-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
2"
OLW
011
171306
101CS1P
011-G-0001-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
2"
OLW
011
171307
101CS1P
011-G-0021-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480244
2"
OLW
011
171308
101CS1P
011-G-0021-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
2"
OLW
011
171309
101CS1P
011-G-0002-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
2"
OLW
011
171310
101CS1P
011-G-0002-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
2"
OLW
011
171311
101CS1P
011-G-0004-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
2"
OLW
011
171312
101CS1P
011-G-0004-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
2"
OLW
011
171313
101CS1P
011-G-0007-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
2"
OLW
011
171314
101CS1P
011-G-0007-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480246
2"
OLW
011
171315
101CS1P
011-G-0010-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480246
2"
OLW
011
171316
101CS1P
011-G-0010-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480263
2"
OLW
011
171317
101CS1P
011-G-0012-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480263
2"
OLW
011
171318
101CS1P
011-G-0012-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480247
2"
OLW
011
171319
101CS1P
011-G-0014-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480247
2"
OLW
011
171320
101CS1P
011-G-0014-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480247
2"
OLW
011
171321
101CS1P
011-G-0016-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480247
2"
OLW
011
171322
101CS1P
011-G-0016-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480248
2"
OLW
011
171323
101CS1P
011-G-0020-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480248
2"
OLW
011
171324
101CS1P
011-G-0020-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
55.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480248
2"
OLW
011
171325
101CS1P
011-G-0022-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480248
2"
OLW
011
171326
101CS1P
011-G-0022-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
2"
OLW
011
171327
101CS1P
011-G-0017-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480245
2"
OLW
011
171328
101CS1P
011-G-0017-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480249
2"
OLW
011
171329
101CS1P
011-G-0026-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480249
2"
OLW
011
171330
101CS1P
011-G-0026-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480251
2"
OLW
011
171331
101CS1P
011-G-0027
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
2"
OLW
011
171332
101CS1P
011-G-0028-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
2"
OLW
011
171333
101CS1P
011-G-0028-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480247
2"
OLW
011
171334
101CS1P
011-G-0018-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480247
2"
OLW
011
171335
101CS1P
011-G-0018-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480251
2"
OLW
011
171336
101CS1P
011-G-0003-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480251
2"
OLW
011
171337
101CS1P
011-G-0003-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480252
2"
OLW
011
171338
101CS1P
011-G-0008-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480252
2"
OLW
011
171339
101CS1P
011-G-0009-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480252
2"
OLW
011
171340
101CS1P
011-G-0009-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480253
2"
OLW
011
171341
101CS1P
011-G-0015-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480253
2"
OLW
011
171342
101CS1P
011-G-0015-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480253
2"
OLW
011
171343
101CS1P
011-G-0005-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480253
2"
OLW
011
171344
101CS1P
011-G-0005-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480252
2"
OLW
011
171345
101CS1P
011-G-0008-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480249
2"
OLW
011
171346
101CS1P
011-PZV-0640
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480250
2"
OLW
011
171347
101CS1P
011-G-0024-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480250
2"
OLW
011
171348
101CS1P
011-G-0024-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
1"
OLW
011
200301
101CS1P
SAMPLE COOLER
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
1"
OLW
011
200306
101CS1P
SAMPLE COOLER
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
1"
OLW
011
200307
101CS1P
SAMPLE COOLER
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
1"
OLW
011
200308
101CS1P
SAMPLE COOLER
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480273
1"
OLW
011
200309
101CS1P
SAMPLE COOLER
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
1"
OLW
011
200310
101CS1P
SAMPLE COOLER
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480275
1"
OLW
011
200311
101CS1P
SAMPLE COOLER
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480275
1"
OLW
011
200312
101CS1P
SAMPLE COOLER
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480273
1"
OLW
011
200313
101CS1P
SAMPLE COOLER
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480275
1"
OLW
011
200314
101CS1P
SAMPLE COOLER
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
1"
OLW
011
200315
101CS1P
SAMPLE COOLER
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480275
1"
OLW
011
200316
101CS1P
SAMPLE COOLER
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
Page 138 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480274
1"
OLW
011
200317
101CS1P
SAMPLE COOLER
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
1"
OLW
011
200319
101CS1P
SAMPLE COOLER
OSW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480275
1"
OLW
011
200321
101CS1P
SAMPLE COOLER
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
1"
OLW
011
200322
101CS1P
SAMPLE COOLER
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
1"
OLW
011
200323
101CS1P
SAMPLE COOLER
OSW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480275
1"
OLW
011
200324
101CS1P
SAMPLE COOLER
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
1"
OLW
011
200325
101CS1P
SAMPLE COOLER
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
1"
OLW
011
200326
101CS1P
2"-CND-011200302-103CS1P-N
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
1"
OLW
011
200327
101CS1P
SAMPLE COOLER
OSW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
4"
OLW
011
200328
101CS1P
SAMPLE COOLER
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
4"
OLW
011
200329
101CS1P
SAMPLE COOLER
OLW
-
-
N
-
WATER
Liquid
1000
0.00
27.00
-
-
0.00
60.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
1/2"
OLW
011
200330
103CS1P
Reducer
SO
-
-
N
-
HVGO
Liquid
853
10.15
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
1/2"
OLW
011
200331
103CS1P
Reducer
SO
-
-
N
-
LAGO
Liquid
809.6
11.10
50.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
1/2"
OLW
011
200332
103CS1P
Reducer
SO
-
-
N
-
LVGO
Liquid
862.5
11.50
50.00
-
-
21.00
80.00
-
H
31.50
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480274
1/2"
OLW
011
200333
103CS1P
Reducer
SO
-
-
N
-
KERO
Liquid
765
10.00
43.00
-
-
18.30
80.00
-
H
27.45
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480289
3/4"
OLW
011
230301
101CS1P
3/4"-DIE-011230001-101CS1P-N
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
55.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480290
3/4"
OLW
011
230302
101CS1P 3/4"-HFO-011230101-101CS1P-P
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
55.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480291
1/2"
OLW
011
230303
101CS1P
Blind flange
Reducer
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
55.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480291
1"
OLW
011
230303
101CS1P
Reducer
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
55.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480289
1"
OLW
011
230304
101CS1P
011-AS-0001
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
55.00
-
Visual Test
ASME 0.00 N/A
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480290
1"
OLW
011
230305
101CS1P
Blind flange
OLW
-
-
N
-
VACUUM RESIDUE
Liquid
956
0.00
27.00
-
-
0.00
55.00
-
Visual Test
ASME 0.00 N/A
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480269
1-1/2"
OLW
011
403301
101CS1P
011-K-0002-A
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
55.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480269
1-1/2"
OLW
011
403302
101CS1P
011-K-0002-B
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
55.00
-
Visual Test
0.00
ASME N/A
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480269
1-1/2"
OLW
011
403303
101CS1P
011-K-0002-C
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
55.00
-
Visual Test
0.00
ASME N/A
By Vendor
By Vendor
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480267
3/4"
OLW
011
405301
101CS1P
3/4"-LUB-011405409-101SD0P-N
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
50.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480267
1-1/2"
OLW
011
405302
101CS1P
011-D-0035
OLW
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
50.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480268
2"
OLW
011
405303
101CS1P
011-K-0003
Reducer
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
50.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480268
1-1/2"
OLW
011
405303
101CS1P
Reducer
1-1/2"-OLW-011405307-101CS1PN
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
50.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480268
2"
OLW
011
405304
101CS1P
011-K-0003
Reducer
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
50.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480268
1-1/2"
OLW
011
405304
101CS1P
Reducer
1-1/2"-OLW-011405307-101CS1PN
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
50.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480268
2"
OLW
011
405307
101CS1P
011-K-0003
Reducer
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
50.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480268
1-1/2"
OLW
011
405307
101CS1P
Reducer
FDP
-
-
N
-
OILY WATER
Liquid
1000
0.00
27.00
-
-
0.00
50.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480209
2"
POW
011
073301
301PU0W
IP-5012-S
HEADER
-
-
N
-
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
2"
POW
011
073301
301PU0W 2"-POW-011073301-301PU0W-N 2"-POW-011073318-301PU0W-N
-
-
N
-
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
2"
POW
011
073302
301PU0W 2"-POW-011073301-301PU0W-N 2"-POW-011073307-301CG0W-F
-
-
N
-
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
2"
POW
011
073303
301PU0W 2"-POW-011073301-301PU0W-N 2"-POW-011073308-301CG0W-F
-
-
N
-
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
2"
POW
011
073304
301PU0W 2"-POW-011073301-301PU0W-N 2"-POW-011073310-301CG0W-F
-
-
N
-
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
2"
POW
011
073305
301PU0W 2"-POW-011073301-301PU0W-N 2"-POW-011073309-301CG0W-F
-
-
N
-
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
2"
POW
011
073306
301PU0W 2"-POW-011073301-301PU0W-N 2"-POW-011073311-301CG0W-F
-
-
N
-
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
2"
POW
011
073307
301CG0W 2"-POW-011073302-301PU0W-N
Reducer
-
-
F
40
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
1-1/2"
POW
011
073307
301CG0W
End
-
-
F
40
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
2"
POW
011
073308
301CG0W 2"-POW-011073303-301PU0W-N
Reducer
-
-
F
40
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
1-1/2"
POW
011
073308
301CG0W
End
-
-
F
40
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
2"
POW
011
073309
301CG0W 2"-POW-011073305-301PU0W-N
SA-JER-DS011-TRJR-480209
1-1/2"
POW
011
073309
301CG0W
SA-JER-DS011-TRJR-480209
2"
POW
011
073310
301CG0W 2"-POW-011073304-301PU0W-N
SA-JER-DS011-TRJR-480209
1-1/2"
POW
011
073310
301CG0W
SA-JER-DS011-TRJR-480209
2"
POW
011
073311
301CG0W 2"-POW-011073306-301PU0W-N
SA-JER-DS011-TRJR-480209
1-1/2"
POW
011
073311
301CG0W
SA-JER-DS011-TRJR-480209
2"
POW
011
073312
SA-JER-DS011-TRJR-480209
2"
POW
011
SA-JER-DS011-TRJR-480209
2"
POW
011
SA-JER-DS011-TRJR-480209
2"
POW
SA-JER-DS011-TRJR-480209
1-1/2"
SA-JER-DS011-TRJR-480209
Reducer
Reducer
Reducer
-
-
F
40
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
End
-
-
F
40
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
Reducer
-
-
F
40
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
011-SP-0102
-
-
F
40
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
Reducer
-
-
F
40
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
End
-
-
F
40
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
301PU0W 2"-POW-011073301-301PU0W-N 2"-POW-011073316-301CG0W-F
-
-
N
-
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
NO
NO
N
N
N
N
N
N
-
-
073313
301PU0W 2"-POW-011073301-301PU0W-N 2"-POW-011073317-301CG0W-F
-
-
N
-
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
NO
NO
N
N
N
N
N
N
-
-
073315
301PU0W
2"-POW-011073301-301PU0W-N
-
-
N
-
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
NO
NO
N
N
N
N
N
N
-
-
011
073316
301CG0W 2"-POW-011073312-301PU0W-N
Reducer
-
-
F
40
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
POW
011
073316
301CG0W
End
-
-
F
40
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
2"
POW
011
073317
301CG0W 2"-POW-011073313-301PU0W-N
Reducer
-
-
F
40
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
1-1/2"
POW
011
073317
301CG0W
011-SP-0105
-
-
F
40
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
2"
POW
011
073318
301PU0W 2"-POW-011073301-301PU0W-N 2"-POW-011073319-301CG0W-F
-
-
N
-
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
2"
POW
011
073319
301CG0W 2"-POW-011073318-301PU0W-N
SA-JER-DS011-TRJR-480209
1-1/2"
POW
011
073319
301CG0W
SA-JER-DS011-TRJR-480209
2"
POW
011
073320
301CG0W 2"-POW-011073321-301PU0W-N
SA-JER-DS011-TRJR-480209
1-1/2"
POW
011
073320
301CG0W
SA-JER-DS011-TRJR-480209
2"
POW
011
073321
SA-JER-DS011-TRJR-480080
56"
PRO
011
SA-JER-DS011-TRJR-480080
60"
PRO
011
Reducer
Reducer
Reducer
End
Reducer
Reducer
Reducer
-
-
F
40
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
End
-
-
F
40
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
Reducer
-
-
F
40
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
End
-
-
F
40
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
301PU0W 2"-POW-011073302-301PU0W-N 2"-POW-011073320-301CG0W-F
-
-
N
-
POTABLE WATER
Liquid
997
4.00
25.00
-
-
8.00
80.00
-
H
12.00
D
NO
NO
N
N
N
N
N
N
-
-
030001
101CH4S
030001
Reducer
Reducer
011-C-0003
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
ALTERNATE DESIGN TEMPERATURE: 222 ºC. NOTE 6
-
-
P
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
NFS
YES
M
ALTERNATE DESIGN TEMPERATURE: 222 ºC. NOTE 6
101CH4S
Reducer
SA-JER-DS011-TRJR-480083
25
VDU OFF GAS
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480080
1"
PRO
011
030001
101CH4S
60"-PRO-011030001-101CH4S-P
011-PT-0067
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
ALTERNATE DESIGN TEMPERATURE: 222 ºC. NOTE 6
SA-JER-DS011-TRJR-480083
60"
PRO
011
030001
101CH4S
SA-JER-DS011-TRJR-480080
HEADER
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 222 ºC. MAX.
SA-JER-DS011-TRJR-480083
60"
PRO
011
030001
101CH4S
60"-PRO-011030001-101CH4S-P
HEADER
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 222 ºC. MAX.
SA-JER-DS011-TRJR-480083
60"
PRO
011
030001
101CH4S
60"-PRO-011030001-101CH4S-P
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 222 ºC. MAX.
SA-JER-DS011-TRJR-480083
60"
PRO
011
030001
101CH4S
60"-PRO-011030001-101CH4S-P
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 222 ºC. MAX.
SA-JER-DS011-TRJR-480083
46"
PRO
011
030001
101CH4S
Reducer
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 222 ºC. MAX.
SA-JER-DS011-TRJR-480083
46"
PRO
011
030001
101CH4S
Reducer
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 222 ºC. MAX.
SA-JER-DS011-TRJR-480083
36"
PRO
011
030001
101CH4S
Reducer
011-E-0025-C
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 222 ºC. MAX.
SA-JER-DS011-TRJR-480083
36"
PRO
011
030001
101CH4S
Reducer
011-E-0025-D
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 222 ºC. MAX.
SA-JER-DS011-TRJR-480080
56"
PRO
011
030002
101CH4S
011-C-0003
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
ALTERNATE DESIGN TEMPERATURE: 222 ºC. NOTE 6
SA-JER-DS011-TRJR-480080
60"
PRO
011
030002
101CH4S
Reducer
SA-JER-DS011-TRJR-480082
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
ALTERNATE DESIGN TEMPERATURE: 222 ºC. NOTE 6
SA-JER-DS011-TRJR-480080
2"
PRO
011
030002
101CH4S
60"-PRO-011030002-101CH4S-P
011-TT-0205
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
ALTERNATE DESIGN TEMPERATURE: 222 ºC. NOTE 6
SA-JER-DS011-TRJR-480080
2"
PRO
011
030002
101CH4S
60"-PRO-011030002-101CH4S-P
011-TT-0198
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
ALTERNATE DESIGN TEMPERATURE: 222 ºC. NOTE 6
SA-JER-DS011-TRJR-480080
1"
PRO
011
030002
101CH4S
60"-PRO-011030002-101CH4S-P
011-PT-0305
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
ALTERNATE DESIGN TEMPERATURE: 222 ºC. NOTE 6
SA-JER-DS011-TRJR-480082
60"
PRO
011
030002
101CH4S
SA-JER-DS011-TRJR-480080
HEADER
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480082
60"
PRO
011
030002
101CH4S
60"-PRO-011030002-101CH4S-P
HEADER
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480082
60"
PRO
011
030002
101CH4S
60"-PRO-011030002-101CH4S-P
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480082
60"
PRO
011
030002
101CH4S
60"-PRO-011030002-101CH4S-P
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480082
46"
PRO
011
030002
101CH4S
Reducer
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480082
46"
PRO
011
030002
101CH4S
Reducer
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480082
36"
PRO
011
030002
101CH4S
Reducer
011-E-0025-A
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480082
36"
PRO
011
030002
101CH4S
Reducer
011-E-0025-B
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480080
24"
PRO
011
030003
101CH4S
011-C-0003
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-380001
ALTERNATE TEMPERATURE DESIGN=222ºC. NOTE 6 ALTERNATE TEMPERATURE DESIGN=222ºC. NOTE 6 ALTERNATE TEMPERATURE DESIGN=222ºC. NOTE 6 ALTERNATE TEMPERATURE DESIGN=222ºC. NOTE 6 ALTERNATE TEMPERATURE DESIGN=222ºC. NOTE 6 ALTERNATE TEMPERATURE DESIGN=222ºC. NOTE 6 ALTERNATE TEMPERATURE DESIGN=222ºC. NOTE 6 ALTERNATE TEMPERATURE DESIGN=222ºC. NOTE 6 MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTES 6, 10
Page 139 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480080
8"
PRO
011
030003
101CH4S
Reducer
011-PZV-0019-A
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10
SA-JER-DS011-TRJR-480080
14"
PRO
011
030003
101CH4S
24"-PRO-011030003-101CH4S-P
011-SP-0029
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTES 6, 10
SA-JER-DS011-TRJR-480080
14"
PRO
011
030003
101CH4S
011-SP-0029
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10
SA-JER-DS011-TRJR-480080
8"
PRO
011
030003
101CH4S
Reducer
011-PZV-0019-B
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10
SA-JER-DS011-TRJR-480080
2"
PRO
011
030003
101CH4S
14"-PRO-011030003-101CH4S-P
2"-PRO-011030003-101CH4S-P
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTES 6, 10
SA-JER-DS011-TRJR-480080
2"
PRO
011
030003
101CH4S
2"-PRO-011030003-101CH4S-P
2"-LFL-011030301-101CH2F-N
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10
SA-JER-DS011-TRJR-480080
1"
PRO
011
030003
101CH4S
2"-PRO-011030003-101CH4S-P
Blind flange
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10
SA-JER-DS011-TRJR-480080
1"
PRO
011
030003
101CH4S
14"-PRO-011030003-101CH4S-P
1"-LFL-011030301-101CH2F-N
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 6, 10
SA-JER-DS011-TRJR-480080
1"
PRO
011
030003
101CH4S
1"-PRO-011030003-101CH4S-P
Blind flange
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 6, 10
SA-JER-DS011-TRJR-480080
1"
PRO
011
030003
101CH4S
14"-PRO-011030003-101CH4S-P
1"-LFL-011030301-101CH2F-N
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 6, 10
SA-JER-DS011-TRJR-480080
1"
PRO
011
030003
101CH4S
1"-PRO-011030003-101CH4S-P
Blind flange
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 6, 10
SA-JER-DS011-TRJR-480080
1"
PRO
011
030003
101CH4S
14"-PRO-011030003-101CH4S-P
1"-LFL-011030301-101CH2F-N
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 6, 10
SA-JER-DS011-TRJR-480080
1"
PRO
011
030003
101CH4S
1"-PRO-011030003-101CH4S-P
Blind flange
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 6, 10
SA-JER-DS011-TRJR-480080
1"
PRO
011
030003
101CH4S
14"-PRO-011030003-101CH4S-P
1"-LFL-011030301-101CH2F-N
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 6, 10
SA-JER-DS011-TRJR-480080
1"
PRO
011
030003
101CH4S
1"-PRO-011030003-101CH4S-P
Blind flange
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 6, 10
SA-JER-DS011-TRJR-480080
14"
PRO
011
030003
101CH4S
Reducer
011-SP-0029
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTES 6, 10
SA-JER-DS011-TRJR-480080
14"
PRO
011
030003
101CH4S
011-SP-0029
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10
SA-JER-DS011-TRJR-480080
6"
PRO
011
030003
101CH4S
Reducer
011-PZV-0019-C
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10
SA-JER-DS011-TRJR-480080
14"
PRO
011
030003
101CH4S
24"-PRO-011030003-101CH4S-P
011-SP-0029
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTES 6, 10
SA-JER-DS011-TRJR-480080
14"
PRO
011
030003
101CH4S
011-SP-0029
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10
SA-JER-DS011-TRJR-480080
8"
PRO
011
030003
101CH4S
Reducer
011-PZV-0020
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10
SA-JER-DS011-TRJR-480080
14"
PRO
011
030003
101CH4S
24"-PRO-011030003-101CH4S-P
011-SP-0029
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTES 6, 10
SA-JER-DS011-TRJR-480080
14"
PRO
011
030003
101CH4S
011-SP-0029
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
MAX. TEMPERATURE FOR PARTIAL POWER FAILURE: 390°C NOTE 10
N
POTENTIAL
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
N
POTENTIAL
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
N
POTENTIAL
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
N
POTENTIAL
N
Y
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@200ºC
if insulated M or Q SA-JER-DS011-TRJR-480080
-
PRO
011
030601
101CH4S
011-C-0003
TRIM
-
-
H
-
-
-
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480080
6"
PRO
011
030601
101CH4S
011-C-0003
Blind flange
-
-
H
40
-
-
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
SA-JER-DS011-TRJR-480080
-
PRO
011
030602
103CH4S
011-C-0003
TRIM
-
-
H
-
-
-
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480080
2"
PRO
011
030602
103CH4S
011-C-0003
011-PI-0066
-
-
H
25
-
-
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
SA-JER-DS011-TRJR-480082
16"
PRO
011
031001
101CH4S
011-E-0025-A
Reducer
-
-
H
40
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480082
18"
PRO
011
031001
101CH4S
Reducer
28"-PRO-011031001-101CH4S-H
-
-
H
40
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
SA-JER-DS011-TRJR-480083
28"
PRO
011
031001
101CH4S
SA-JER-DS011-TRJR-480082
SA-JER-DS011-TRJR-480083
26"
PRO
011
031001
101CH4S 28"-PRO-011031001-101CH4S-H
SA-JER-DS011-TRJR-480083
16"
PRO
011
031001
101CH4S
SA-JER-DS011-TRJR-480083
16"
PRO
011
031001
SA-JER-DS011-TRJR-480083
18"
PRO
011
SA-JER-DS011-TRJR-480083
18"
PRO
SA-JER-DS011-TRJR-480082
28"
SA-JER-DS011-TRJR-480084
26"
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
ALTERNATE DESIGN TEMPERATURE=145ºC. NOTE 6 ALTERNATE DESIGN TEMPERATURE=145ºC. NOTE 6
HEADER
-
-
H
40
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 222 ºC. MAX.
SA-JER-DS011-TRJR-480084
-
-
H
40
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 222 ºC. MAX.
011-E-0025-C
Reducer
-
-
H
40
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 222 ºC. MAX.
101CH4S
011-E-0025-D
Reducer
-
-
H
40
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 222 ºC. MAX.
031001
101CH4S
Reducer
28"-PRO-011031001-101CH4S-H
-
-
H
40
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 222 ºC. MAX.
011
031001
101CH4S
Reducer
28"-PRO-011031001-101CH4S-H
-
-
H
40
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 222 ºC. MAX.
PRO
011
031001
101CH4S
HEADER
SA-JER-DS011-TRJR-480083
-
-
H
40
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
ALTERNATE DESIGN TEMPERATURE=145ºC. NOTE 6
PRO
011
031001
101CH4S
SA-JER-DS011-TRJR-480083
Reducer
-
-
H
40
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 145ºC.
SA-JER-DS011-TRJR-480084
1"
PRO
011
031001
101CH4S 26"-PRO-011031001-101CH4S-H
011-PI-0495
-
-
H
25
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 145ºC.
SA-JER-DS011-TRJR-480084
24"
PRO
011
031001
101CH4S
Reducer
011-J-0001-C
-
-
H
40
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 145ºC.
SA-JER-DS011-TRJR-480082
16"
PRO
011
031001
101CH4S
011-E-0025-B
Reducer
-
-
H
40
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
ALTERNATE DESIGN TEMPERATURE=145ºC.
SA-JER-DS011-TRJR-480082
18"
PRO
011
031001
101CH4S
Reducer
28"-PRO-011031001-101CH4S-H
-
-
H
40
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
ALTERNATE DESIGN TEMPERATURE=145ºC.
SA-JER-DS011-TRJR-480082
26"
PRO
011
031002
101CH4S 28"-PRO-011031001-101CH4S-H
SA-JER-DS011-TRJR-480084
-
-
H
40
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
ALTERNATE DESIGN TEMPERATURE: 145ºC. NOTE 6
SA-JER-DS011-TRJR-480084
26"
PRO
011
031002
101CH4S
Reducer
-
-
H
40
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
1"
PRO
011
031002
101CH4S 26"-PRO-011031002-101CH4S-H
011-PI-0075
-
-
H
25
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
24"
PRO
011
031002
101CH4S
011-J-0001-A
-
-
H
40
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480083
26"
PRO
011
031003
101CH4S 28"-PRO-011031001-101CH4S-H
SA-JER-DS011-TRJR-480084
-
-
H
40
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 222 ºC. MAX.
SA-JER-DS011-TRJR-480084
26"
PRO
011
031003
101CH4S
Reducer
-
-
H
40
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.42
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 145ºC.
SA-JER-DS011-TRJR-480084
1"
PRO
011
031003
101CH4S 26"-PRO-011031003-101CH4S-H
011-PI-0494
-
-
H
25
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 145ºC.
SA-JER-DS011-TRJR-480084
24"
PRO
011
031003
101CH4S
Reducer
011-J-0001-B
-
-
H
40
VDU OFF GAS
Gas
-
-0.90
44.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 145ºC.
SA-JER-DS011-TRJR-480082
2"
PRO
011
031004
103CH4S
60"-PRO-011030002-101CH4S-P
011-AT-0035
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
80.00
-
-
3.50
-1.00
120.00
120.00
-
H
5.25
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
ALTERNATE TEMPERATURE DESIGN=222ºC. NOTE 6
SA-JER-DS011-TRJR-480084
32"
PRO
011
032001
101CH4S
HEADER
SA-JER-DS011-TRJR-480085
-
-
P
25
VDU OFF GAS
Gas
-
-0.83
132.00
-
-
3.50
-1.00
300.00
300.00
-
H
6.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480085
32"
PRO
011
032001
101CH4S
SA-JER-DS011-TRJR-480084
011-E-0026
-
-
P
25
VDU OFF GAS
Gas
-
-0.83
132.00
-
-
3.50
-1.00
300.00
300.00
-
H
6.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480085
12"
PRO
011
032002
101CH4S
011-E-0026
SA-JER-DS011-TRJR-480084
-
-
H
40
VDU OFF GAS
Gas
-
-0.84
45.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
12"
PRO
011
032002
101CH4S
SA-JER-DS011-TRJR-480085
HEADER
-
-
H
40
VDU OFF GAS
Gas
-
-0.84
45.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
1"
PRO
011
032002
101CH4S 12"-PRO-011032002-101CH4S-H
011-PI-0104
-
-
H
25
VDU OFF GAS
Gas
-
-0.84
45.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
18"
PRO
011
032003
101CH4S
HEADER
SA-JER-DS011-TRJR-480085
-
-
P
25
VDU OFF GAS
Gas
-
-0.64
139.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480085
18"
PRO
011
032003
101CH4S
SA-JER-DS011-TRJR-480084
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.64
139.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480085
12"
PRO
011
032003
101CH4S
Reducer
011-E-0027
-
-
P
25
VDU OFF GAS
Gas
-
-0.64
139.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
SA-JER-DS011-TRJR-480082
Reducer
SA-JER-DS011-TRJR-480083
Page 140 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
INSULATION (NOTE 2)
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
011-E-0027
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480085
8"
PRO
011
032004
101CH4S
SA-JER-DS011-TRJR-480084
-
-
H
40
VDU OFF GAS
Gas
-
-0.55
45.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
8"
PRO
011
032004
101CH4S
SA-JER-DS011-TRJR-480085
HEADER
-
-
H
40
VDU OFF GAS
Gas
-
-0.55
45.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
1"
PRO
011
032004
101CH4S
8"-PRO-011032004-101CH4S-H
011-PI-0105
-
-
H
25
VDU OFF GAS
Gas
-
-0.55
45.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
10"
PRO
011
032005
101CH4S
HEADER
SA-JER-DS011-TRJR-480085
-
-
P
40
VDU OFF GAS
Gas
-
0.32
178.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480085
10"
PRO
011
032005
101CH4S
SA-JER-DS011-TRJR-480084
Reducer
-
-
P
40
VDU OFF GAS
Gas
-
0.32
178.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480085
6"
PRO
011
032005
101CH4S
Reducer
011-E-0028
-
-
P
40
VDU OFF GAS
Gas
-
0.32
178.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
18"
PRO
011
032006
101CH4S
011-J-0001-A
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.83
132.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
20"
PRO
011
032006
101CH4S
Reducer
32"-PRO-011032001-101CH4S-P
-
-
P
25
VDU OFF GAS
Gas
-
-0.83
132.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
18"
PRO
011
032007
101CH4S
011-J-0001-B
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.83
132.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
20"
PRO
011
032007
101CH4S
Reducer
32"-PRO-011032001-101CH4S-P
-
-
P
25
VDU OFF GAS
Gas
-
-0.83
132.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
18"
PRO
011
032008
101CH4S
011-J-0001-C
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.83
132.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
20"
PRO
011
032008
101CH4S
Reducer
32"-PRO-011032001-101CH4S-P
-
-
P
25
VDU OFF GAS
Gas
-
-0.83
132.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
8"
PRO
011
032009
101CH4S 12"-PRO-011032002-101CH4S-H
Reducer
-
-
H
40
VDU OFF GAS
Gas
-
-0.84
45.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
6"
PRO
011
032009
101CH4S
011-J-0002-A
-
-
H
40
VDU OFF GAS
Gas
-
-0.84
45.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
8"
PRO
011
032010
101CH4S 12"-PRO-011032002-101CH4S-H
Reducer
-
-
H
40
VDU OFF GAS
Gas
-
-0.84
45.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
6"
PRO
011
032010
101CH4S
011-J-0002-B
-
-
H
40
VDU OFF GAS
Gas
-
-0.84
45.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
8"
PRO
011
032011
101CH4S 12"-PRO-011032002-101CH4S-H
Reducer
-
-
H
40
VDU OFF GAS
Gas
-
-0.84
45.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
6"
PRO
011
032011
101CH4S
Reducer
011-J-0002-C
-
-
H
40
VDU OFF GAS
Gas
-
-0.84
45.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
6"
PRO
011
032012
101CH4S
011-J-0002-A
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.64
139.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
10"
PRO
011
032012
101CH4S
Reducer
18"-PRO-011032003-101CH4S-P
-
-
P
25
VDU OFF GAS
Gas
-
-0.64
139.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
6"
PRO
011
032013
101CH4S
011-J-0002-B
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.64
139.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
10"
PRO
011
032013
101CH4S
Reducer
18"-PRO-011032003-101CH4S-P
-
-
P
25
VDU OFF GAS
Gas
-
-0.64
139.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
Reducer
Reducer
SA-JER-DS011-TRJR-480084
6"
PRO
011
032014
101CH4S
011-J-0002-C
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.64
139.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
10"
PRO
011
032014
101CH4S
Reducer
18"-PRO-011032003-101CH4S-P
-
-
P
25
VDU OFF GAS
Gas
-
-0.64
139.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
6"
PRO
011
032015
101CH4S
8"-PRO-011032004-101CH4S-H
Reducer
-
-
H
40
VDU OFF GAS
Gas
-
-0.55
45.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
4"
PRO
011
032015
101CH4S
Reducer
011-J-0003-A
-
-
H
25
VDU OFF GAS
Gas
-
-0.55
45.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
6"
PRO
011
032016
101CH4S
8"-PRO-011032004-101CH4S-H
Reducer
-
-
H
40
VDU OFF GAS
Gas
-
-0.55
45.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
4"
PRO
011
032016
101CH4S
Reducer
011-J-0003-B
-
-
H
25
VDU OFF GAS
Gas
-
-0.55
45.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
6"
PRO
011
032017
101CH4S
8"-PRO-011032004-101CH4S-H
Reducer
-
-
H
40
VDU OFF GAS
Gas
-
-0.55
45.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
4"
PRO
011
032017
101CH4S
Reducer
011-J-0003-C
-
-
H
25
VDU OFF GAS
Gas
-
-0.55
45.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
M
YES
M or Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
4"
PRO
011
032018
101CH4S
011-J-0003-A
Reducer
-
-
P
40
VDU OFF GAS
Gas
-
0.32
178.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
8"
PRO
011
032018
101CH4S
Reducer
10"-PRO-011032005-101CH4S-P
-
-
P
40
VDU OFF GAS
Gas
-
0.32
178.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
4"
PRO
011
032019
101CH4S
011-J-0003-B
Reducer
-
-
P
40
VDU OFF GAS
Gas
-
0.32
178.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
8"
PRO
011
032019
101CH4S
Reducer
10"-PRO-011032005-101CH4S-P
-
-
P
40
VDU OFF GAS
Gas
-
0.32
178.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
4"
PRO
011
032020
101CH4S
011-J-0003-C
Reducer
-
-
P
40
VDU OFF GAS
Gas
-
0.32
178.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
8"
PRO
011
032020
101CH4S
Reducer
10"-PRO-011032005-101CH4S-P
-
-
P
40
VDU OFF GAS
Gas
-
0.32
178.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
Q
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
20"
PRO
011
032021
101CH4S
32"-PRO-011032001-101CH4S-P
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.83
132.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
20"
PRO
011
032021
101CH4S
Reducer
20"-PRO-011032021-101CH4S-P
-
-
P
25
VDU OFF GAS
Gas
-
-0.83
132.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
14"
PRO
011
032021
101CH4S
14"-PRO-011032021-101CH4S-P
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.83
132.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
14"
PRO
011
032021
101CH4S
Reducer
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.83
132.00
-
-
3.50
-1.00
300.00
350.00
-
H
5.92
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480083
28"
PRO
011
032021
101CH4S
SA-JER-DS011-TRJR-480084
60"-PRO-011030001-101CH4S-P
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
132.00
-
-
3.50
-1.00
300.00
300.00
-
H
6.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6. ALTERNATE DESIGN TEMPERATURE 222 ºC. MAX.
SA-JER-DS011-TRJR-480084
28"
PRO
011
032021
101CH4S
Reducer
28"-PRO-011032021-101CH4S-P
-
-
P
25
VDU OFF GAS
Gas
-
-0.83
132.00
-
-
3.50
-1.00
300.00
350.00
-
H
6.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480082
28"
PRO
011
032021
101CH4S
SA-JER-DS011-TRJR-480084
60"-PRO-011030002-101CH4S-P
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
132.00
-
-
3.50
-1.00
300.00
300.00
-
H
6.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
28"
PRO
011
032021
101CH4S
28"-PRO-011032021-101CH4S-P
SA-JER-DS011-TRJR-480083
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
132.00
-
-
3.50
-1.00
300.00
300.00
-
H
6.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
28"
PRO
011
032021
101CH4S
28"-PRO-011032021-101CH4S-P
SA-JER-DS011-TRJR-480082
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
132.00
-
-
3.50
-1.00
300.00
300.00
-
H
6.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
14"
PRO
011
032021
101CH4S
Reducer
14"-PRO-011032021-101CH4S-P
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
132.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
28"
PRO
011
032021
101CH4S
28"-PRO-011032021-101CH4S-P
Reducer
-
-
P
25
VDU OFF GAS
Gas
-
-0.90
132.00
-
-
3.50
-1.00
300.00
300.00
-
H
6.42
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
1"
PRO
011
032022
101CH4S
28"-PRO-011032021-101CH4S-P
1"-LFL-011032302-101CH2F-N
-
-
P
25
VDU OFF GAS
Gas
-
-0.83
132.00
-
-
3.50
-1.00
300.00
300.00
-
H
5.92
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
3/4"
PRO
011
032022
101CH4S
1"-PRO-011032022-101CH4S-P
Blind flange
-
-
P
25
VDU OFF GAS
Gas
-
-0.83
132.00
-
-
3.50
-1.00
300.00
300.00
-
-
-
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480084
3/4"
PRO
011
032022
101CH4S
20"-PRO-011032021-101CH4S-P
1"-PRO-011032022-101CH4S-P
-
-
P
25
VDU OFF GAS
Gas
-
-0.83
132.00
-
-
3.50
-1.00
300.00
300.00
-
-
-
NFS
YES
M
N
POTENTIAL
N
Y
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480086
3"
PRO
011
033001
101CH2S
011-D-0008
SA-JER-DS011-TRJR-480087
-
-
N
-
RECOVERED LVGO
Liquid
749
0.30
50.00
-
-
4.00
-1.00
150.00
100.00
-
H
6.00
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
3"
PRO
011
033001
101CH2S
SA-JER-DS011-TRJR-480086
3"-PRO-011033005-103CH2S-N
-
-
N
-
RECOVERED LVGO
Liquid
749
0.30
50.00
-
-
4.00
-1.00
150.00
100.00
-
H
6.00
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
1"
PRO
011
033002
103CH2S
011-G-0020-A
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
2"
PRO
011
033002
103CH2S
Reducer
2"-PRO-011033002-103CH2S-N
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480248
3/4"
PRO
011
033002
103CH2S
SA-JER-DS011-TRJR-480087
2"-OLW-011171323-101CS1P-N
-
-
N
-
RECOVERED LVGO
Liquid
749
0.00
27.00
-
-
0.00
60.00
-
H
0.00
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
2"
PRO
011
033002
103CH2S
2"-PRO-011033002-103CH2S-N
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
1-1/2"
PRO
011
033002
103CH2S
Reducer
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
Reducer
2"-PRO-011033009-103CH2S-N
SA-JER-DS011-TRJR-480087
2"
PRO
011
033002
103CH2S
SA-JER-DS011-TRJR-480087
3/4"
PRO
011
033002
103CH2S
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
2"-PRO-011033002-103CH2S-N 3/4"-PRO-011033002-103CH2S-N
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
-
SA-JER-DS011-TRJR-480248
-
-
N
-
RECOVERED LVGO
Liquid
749
0.00
27.00
-
-
0.00
60.00
-
H
0.00
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
-
011-RO-0005
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
3/4"
PRO
011
033002
103CH2S
3/4"-PRO-011033002-103CH2SN
SA-JER-DS011-TRJR-480087
2"
PRO
011
033003
103CH2S
2"-PRO-011033002-103CH2S-N
SA-JER-DS011-TRJR-480087
2"
PRO
011
033003
103CH2S
011-RO-0005
SA-JER-DS011-TRJR-480086
-
-
N
-
RECOVERED LVGO
Liquid
749
0.70
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480086
2"
PRO
011
033003
103CH2S
SA-JER-DS011-TRJR-480087
2"-PRO-011033024-101CH2S-N
-
-
N
-
RECOVERED LVGO
Liquid
749
0.70
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
3"
PRO
011
033004
103CH2S
3"-PRO-011033001-101CH2S-N
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
0.30
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
2"
PRO
011
033004
103CH2S
Reducer
011-G-0020-A
-
-
N
-
RECOVERED LVGO
Liquid
749
0.30
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
3"
PRO
011
033005
103CH2S
3"-PRO-011033001-101CH2S-N
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
0.30
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
2"
PRO
011
033005
103CH2S
Reducer
011-G-0020-B
-
-
N
-
RECOVERED LVGO
Liquid
749
0.30
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
2"
PRO
011
033006
103CH2S
2"-PRO-011033002-103CH2S-N
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
1-1/2"
PRO
011
033006
103CH2S
Reducer
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
2"
PRO
011
033006
103CH2S
Reducer
2"-PRO-011033006-103CH2S-N
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
2"
PRO
011
033006
103CH2S
2"-PRO-011033006-103CH2S-N
2"-PRO-011033026-103CS1P-N
-
-
N
-
RECOVERED LVGO
Liquid
749
7.70
50.00
-
-
28.30
80.00
-
H
42.45
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
2"
PRO
011
033008
103CH2S
2"-PRO-011033006-103CH2S-N
SA-JER-DS011-TRJR-480060
-
-
N
-
RECOVERED LVGO
Liquid
749
7.70
50.00
-
-
28.30
80.00
-
H
42.45
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480060
2"
PRO
011
033008
103CH2S
SA-JER-DS011-TRJR-480087
2"-DIE-011025014-103CS1P-N
-
-
N
-
RECOVERED LVGO
Liquid
749
7.70
50.00
-
-
28.30
80.00
-
H
42.45
NFS
YES
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
2"
PRO
011
033009
103CH2S
2"-PRO-011033002-103CH2S-N
SA-JER-DS011-TRJR-480136
-
-
N
-
RECOVERED LVGO
Liquid
749
6.00
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
2"
PRO
011
033009
103CH2S
SA-JER-DS011-TRJR-480087
2"-PRO-011098001-103CS1P-S
-
-
N
-
RECOVERED LVGO
Liquid
749
6.00
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480086
3/4"
PRO
011
033010
101CH2S
011-LG-0056
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
0.30
50.00
-
-
4.00
150.00
-
H
6.00
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480086
2"
PRO
011
033010
101CH2S
Reducer
2"-CLD-011033301-101CH2S-N
-
-
N
-
RECOVERED LVGO
Liquid
749
0.30
50.00
-
-
4.00
150.00
-
H
6.00
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
3/4"
PRO
011
033011
103CH2S
2"-PRO-011033003-103CH2S-N
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
0.70
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
2"
PRO
011
033011
103CH2S
Reducer
2"-CLD-011033302-101CH2S-N
-
-
N
-
RECOVERED LVGO
Liquid
749
0.70
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
1"
PRO
011
033012
103CH2S
011-G-0020-B
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
2"
PRO
011
033012
103CH2S
Reducer
2"-PRO-011033012-103CH2S-N
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480248
3/4"
PRO
011
033012
103CH2S
SA-JER-DS011-TRJR-480087
2"-OLW-011171324-101CS1P-N
-
-
N
-
RECOVERED LVGO
Liquid
749
0.00
27.00
-
-
0.00
60.00
-
H
0.00
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
-
2"-PRO-011033012-103CH2S-N
2"-PRO-011033002-103CH2S-N
SA-JER-DS011-TRJR-480087
2"
PRO
011
033012
103CH2S
SA-JER-DS011-TRJR-480087
3/4"
PRO
011
033012
103CH2S
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
2"-PRO-011033012-103CH2S-N 3/4"-PRO-011033012-103CH2S-N
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480087
3/4"
PRO
011
033012
103CH2S
-
3/4"-PRO-011033012-103CH2SN
SA-JER-DS011-TRJR-480248
-
-
N
-
RECOVERED LVGO
Liquid
749
0.00
27.00
-
-
0.00
60.00
-
H
0.00
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480087
1-1/2"
PRO
011
033013
103CH2S
2"-PRO-011033002-103CH2S-N
-
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
2"-CLD-011033305-101CH2S-N
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
2"
PRO
011
033013
103CH2S
Reducer
SA-JER-DS011-TRJR-480087
1-1/2"
PRO
011
033013
103CH2S
3"-PRO-011033004-103CH2S-N
SA-JER-DS011-TRJR-480087
1"
PRO
011
033013
103CH2S
Reducer
SA-JER-DS011-TRJR-480087
3/4"
PRO
011
033013
103CH2S
011-G-0020-A
SA-JER-DS011-TRJR-380001
1-1/2"-PRO-011033013-103CH2SN 1-1/2"-PRO-011033013-103CH2SN Reducer
Page 141 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
SA-JER-DS011-TRJR-480087
1-1/2"
PRO
011
033014
103CH2S
2"-PRO-011033012-103CH2S-N
SA-JER-DS011-TRJR-480087
2"
PRO
011
033014
103CH2S
Reducer
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
Reducer
-
-
N
-
2"-CLD-011033306-101CH2S-N
-
-
N
-
-
-
N
-
-
1-1/2"-PRO-011033014-103CH2SN 1-1/2"-PRO-011033014-103CH2SN
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
PRESS. (BARG)
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
STRESS TEMP
TEMP. (ºC)
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
(NOTE 7)
SA-JER-DS011-TRJR-480087
1-1/2"
PRO
011
033014
103CH2S
3"-PRO-011033005-103CH2S-N
SA-JER-DS011-TRJR-480087
1"
PRO
011
033014
103CH2S
Reducer
SA-JER-DS011-TRJR-480087
3/4"
PRO
011
033014
103CH2S
011-G-0020-B
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
3/4"
PRO
011
033015
103CH2S
2"-PRO-011033002-103CH2S-N
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
2"
PRO
011
033015
103CH2S
Reducer
2"-CLD-011033303-101CH2S-N
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
3/4"
PRO
011
033015
103CH2S
2"-PRO-011033002-103CH2S-N 3/4"-PRO-011033015-103CH2S-N
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
3/4"
PRO
011
033016
103CH2S
2"-PRO-011033006-103CH2S-N
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
2"
PRO
011
033016
103CH2S
Reducer
2"-CLD-011033304-101CH2S-N
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480087
3/4"
PRO
011
033016
103CH2S
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480086
2"
PRO
011
033018
101CH2S
011-D-0008
2"-OLW-011033303-101CS1P-N
-
-
N
-
RECOVERED LVGO
Liquid
749
0.30
50.00
-
-
4.00
-
H
6.00
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480087
3/4"
PRO
011
033020
103CH2S
2"-PRO-011033002-103CH2S-N
011-SC-0026
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
2"-PRO-011033006-103CH2S-N 3/4"-PRO-011033016-103CH2S-N
-1.00
150.00
100.00
80.00
NOTE 6 NOTE 6 THIS LINE IS ALREADY DRAW IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. NOTE 6. THIS LINE IS ALREADY DRAW IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE. NOTE 6.
Reducer
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
103CH2S
Reducer
3/4"-PRO-011033021-103CH2S-N
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
103CH2S
3/4"-PRO-011033020-103CH2SN
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
033020
103CH2S
Reducer
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
011
033020
103CH2S
Reducer
SAMPLE CYLINDER
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
-
-
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6.
011
033021
103CH2S
011-SC-0026
2"-PRO-011033003-103CH2S-N
-
-
N
-
RECOVERED LVGO
Liquid
749
0.70
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
0.70
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480275
4"
PRO
011
033020
103CH2S
SA-JER-DS011-TRJR-480275
3/4"
PRO
011
033020
SA-JER-DS011-TRJR-480275
3/4"
PRO
011
033020
SA-JER-DS011-TRJR-480275
1/2"
PRO
011
SA-JER-DS011-TRJR-480275
1/4"
PRO
SA-JER-DS011-TRJR-480087
3/4"
PRO
SA-JER-DS011-TRJR-480275
3/4"
PRO
011
033021
103CH2S
3/4"-PRO-011033021-103CH2SN
SA-JER-DS011-TRJR-480275
1/2"
PRO
011
033021
103CH2S
Reducer
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
0.70
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480275
3/4"
PRO
011
033021
103CH2S
Reducer
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
0.70
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480275
2"
PRO
011
033021
103CH2S
Reducer
2"-CLD-011200309-101CH2S-N
-
-
N
-
RECOVERED LVGO
Liquid
749
0.70
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480275
1/4"
PRO
011
033021
103CH2S
SAMPLE CYLINDER
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
0.70
50.00
-
-
15.50
80.00
-
-
-
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480275
1/2"
PRO
011
033021
103CH2S
Reducer
1/2"-PRO-011033021-103CH2S-N
-
-
N
-
RECOVERED LVGO
Liquid
749
0.70
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480086
2"
PRO
011
033023
101CH2S
UC
011-D-0008
-
-
P
25
RECOVERED LVGO
Liquid
749
0.30
50.00
-
-
3.50
-1.00
250.00
100.00
-
H
5.50
NFS
YES
M
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: 7 BARG+FV@290ºC.
SA-JER-DS011-TRJR-480086
1"
PRO
011
033023
101CH2S
2"-PRO-011033023-101CH2S-P
Blind flange
-
-
P
25
RECOVERED LVGO
Liquid
749
0.30
50.00
-
-
3.50
-1.00
250.00
100.00
-
H
5.50
NFS
YES
M
N
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: 7 BARG+FV@290ºC.
SA-JER-DS011-TRJR-480086
2"
PRO
011
033024
101CH2S
2"-PRO-011033003-103CH2S-N
011-D-0008
-
-
N
-
RECOVERED LVGO
Liquid
749
0.30
50.00
-
-
3.50
-1.00
150.00
100.00
-
H
5.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480087
2"
PRO
011
033025
103CH2S
2"-PRO-011033002-103CH2S-N
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480087
1"
PRO
011
033025
103CH2S
Reducer
011-PZV-0086
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480087
2"
PRO
011
033025
103CH2S
2"-PRO-011033025-103CH2S-N
Reducer
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480087
1"
PRO
011
033025
103CH2S
Reducer
011-PZV-0087
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480087
2"
PRO
011
033025
103CH2S
2"-PRO-011033025-103CH2S-N
2"-LFL-011033305-101CH2F-N
-
-
N
-
RECOVERED LVGO
Liquid
749
9.50
50.00
-
-
15.50
80.00
-
H
23.25
NFS
YES
A or Q
N
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480087
2"
PRO
011
033026
103CS1P
2"-PRO-011033006-103CH2S-N
SA-JER-DS011-TRJR-480098
-
-
N
-
RECOVERED LVGO
Liquid
749
7.70
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480098
2"
PRO
011
033026
103CS1P
SA-JER-DS011-TRJR-480087
6"-DIE-011037007-103CS1P-N
-
-
N
-
RECOVERED LVGO
Liquid
749
7.70
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
N
POTENTIAL
N
N
N
N
-
NOTE 6
N
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS:0.5 BARA(HALF VACUUM)@150°C.
-
NOTE 6
NOTE 6 MAX. TEMPERATURE FOR BACKFLOW: 50ºC NOTE 10 NOTE 6 MAX. TEMPERATURE FOR BACKFLOW: 50ºC NOTE 10 MAX. TEMPERATURE FOR BACKFLOW: 50ºC NOTE 10 NOTE 6 MAX. TEMPERATURE FOR BACKFLOW: 50ºC NOTE 10 MAX. TEMPERATURE FOR BACKFLOW: 50ºC NOTE 10 NOTE 6
if insulated M or Q SA-JER-DS011-TRJR-480086
-
PRO
011
033601
103CH2S
011-D-0008
TRIM
-
-
N
-
-
-
-
0.30
50.00
-
-
4.00
SA-JER-DS011-TRJR-480262
3/4"
PRO
011
035401
101SD0P
2"-PRO-011035409-101CS1P-N
SA-JER-DS011-TRJR-480091
-
-
N
-
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
SA-JER-DS011-TRJR-480091
3/4"
PRO
011
035401
101SD0P
SA-JER-DS011-TRJR-480262
011-KH-0001
-
-
N
-
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
SA-JER-DS011-TRJR-480262
3/4"
PRO
011
035403
101SD0P
2"-PRO-011035409-101CS1P-N
SA-JER-DS011-TRJR-480091
-
-
N
-
LUBE OIL
Liquid
840
6.50
65.00
-
-
SA-JER-DS011-TRJR-480091
3/4"
PRO
011
035403
101SD0P
SA-JER-DS011-TRJR-480262
011-K-0001
-
-
N
-
LUBE OIL
Liquid
840
6.50
65.00
-
-
SA-JER-DS011-TRJR-480262
3/4"
PRO
011
035404
101SD0P
2"-PRO-011035409-101CS1P-N
SA-JER-DS011-TRJR-480091
-
-
N
-
LUBE OIL
Liquid
840
6.50
65.00
-
SA-JER-DS011-TRJR-480091
3/4"
PRO
011
035404
101SD0P
SA-JER-DS011-TRJR-480262
011-K-0001
-
-
N
-
LUBE OIL
Liquid
840
6.50
65.00
SA-JER-DS011-TRJR-480091
3/4"
PRO
011
035405
101SD0P
011-KH-0001
SA-JER-DS011-TRJR-480262
-
-
N
-
LUBE OIL
Liquid
840
0.00
70.00
SA-JER-DS011-TRJR-480262
3/4"
PRO
011
035405
101SD0P
SA-JER-DS011-TRJR-480091
011-D-0028
-
-
N
-
LUBE OIL
Liquid
840
0.00
SA-JER-DS011-TRJR-480262
3/4"
PRO
011
035406
101SD0P
2"-PRO-011035409-101CS1P-N
SA-JER-DS011-TRJR-480091
-
-
N
-
LUBE OIL
Liquid
840
6.50
SA-JER-DS011-TRJR-480091
3/4"
PRO
011
035406
101SD0P
SA-JER-DS011-TRJR-480262
011-K-0001
-
-
N
-
LUBE OIL
Liquid
840
SA-JER-DS011-TRJR-480091
3"
PRO
011
035407
101SD0P
011-K-0001
Reducer
-
-
N
-
LUBE OIL
Liquid
840
SA-JER-DS011-TRJR-480091
4"
PRO
011
035407
101SD0P
Reducer
SA-JER-DS011-TRJR-480262
-
-
N
-
LUBE OIL
Liquid
SA-JER-DS011-TRJR-480262
4"
PRO
011
035407
101SD0P
SA-JER-DS011-TRJR-480091
011-D-0028
-
-
N
-
LUBE OIL
SA-JER-DS011-TRJR-480091
3"
PRO
011
035408
101SD0P
011-K-0001
Reducer
-
-
N
-
LUBE OIL
SA-JER-DS011-TRJR-480091
4"
PRO
011
035408
101SD0P
Reducer
SA-JER-DS011-TRJR-480262
-
-
N
-
SA-JER-DS011-TRJR-480262
4"
PRO
011
035408
101SD0P
SA-JER-DS011-TRJR-480091
011-D-0028
-
-
N
SA-JER-DS011-TRJR-480262
2"
PRO
011
035409
101CS1P
Reducer
011-D-0028
-
-
SA-JER-DS011-TRJR-480262
3"
PRO
011
035409
101CS1P
011-S-0007-B
3"-PRO-011035409-101CS1P-N
-
-
SA-JER-DS011-TRJR-480262
4"
PRO
011
035409
101CS1P
Reducer
Reducer
-
SA-JER-DS011-TRJR-480262
2"
PRO
011
035409
101CS1P
Reducer
Reducer
SA-JER-DS011-TRJR-480262
2"
PRO
011
035409
101CS1P
Reducer
SA-JER-DS011-TRJR-480262
1-1/2"
PRO
011
035409
101CS1P
SA-JER-DS011-TRJR-480262
3"
PRO
011
035409
SA-JER-DS011-TRJR-480262
2"
PRO
011
SA-JER-DS011-TRJR-480262
1-1/2"
PRO
SA-JER-DS011-TRJR-480262
2"
PRO
SA-JER-DS011-TRJR-480262
2"
SA-JER-DS011-TRJR-480262
-
Visual Test
0.00
NFS
YES
120.00
-
H
15.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
120.00
-
H
15.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
10.00
120.00
-
H
15.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
10.00
120.00
-
H
15.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
-
10.00
120.00
-
H
15.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
-
-
10.00
120.00
-
H
15.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
-
-
0.00
120.00
-
H
0.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
70.00
-
-
0.00
120.00
-
H
0.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
65.00
-
-
10.00
120.00
-
H
15.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
6.50
65.00
-
-
10.00
120.00
-
H
15.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
0.00
70.00
-
-
0.00
120.00
-
H
0.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
840
0.00
70.00
-
-
0.00
120.00
-
H
0.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
Liquid
840
0.00
70.00
-
-
0.00
120.00
-
H
0.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
Liquid
840
0.00
70.00
-
-
0.00
120.00
-
H
0.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
LUBE OIL
Liquid
840
0.00
70.00
-
-
0.00
120.00
-
H
0.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
-
LUBE OIL
Liquid
840
0.00
70.00
-
-
0.00
120.00
-
H
0.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
N
-
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
By D Code
A or Q
Y
N
N
N
N
N
By Vendor
-
N
-
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
By D Code
A or Q
Y
N
N
N
N
N
By Vendor
-
-
N
-
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
By D Code
A or Q
Y
N
N
N
N
N
By Vendor
-
-
-
N
-
SOFT CW
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
By D Code
A or Q
Y
N
N
N
N
N
By Vendor
-
Reducer
-
-
N
-
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
By D Code
A or Q
Y
N
N
N
N
N
By Vendor
-
Reducer
Reducer
-
-
N
-
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
D Code By
A or Q
Y
N
N
N
N
N
By Vendor
-
101CS1P
011-S-0007-A
Reducer
-
-
N
-
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
By D Code
A or Q
Y
N
N
N
N
N
By Vendor
-
035409
101CS1P
2"-PRO-011035409-101CS1P-N
Reducer
-
-
N
-
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
By D Code
A or Q
Y
N
N
N
N
N
By Vendor
-
011
035409
101CS1P
Reducer
Reducer
-
-
N
-
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
By D Code
A or Q
Y
N
N
N
N
N
By Vendor
-
011
035409
101CS1P
Reducer
2"-PRO-011035409-101CS1P-N
-
-
N
-
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
By D Code
A or Q
Y
N
N
N
N
N
By Vendor
-
PRO
011
035410
101SD0P
2"-PRO-011035417-101SD0P-P
Reducer
-
-
P
25
LUBE OIL
Liquid
840
7.00
70.00
-
-
10.00
120.00
-
H
15.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
3/4"
PRO
011
035410
101SD0P
2"-PRO-011035410-101SD0P-P
Blind flange
-
-
P
25
LUBE OIL
Liquid
840
7.00
70.00
-
-
10.00
120.00
-
H
15.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
1-1/2"
PRO
011
035410
101SD0P
Reducer
Reducer
-
-
P
25
LUBE OIL
Liquid
840
7.00
70.00
-
-
10.00
120.00
-
H
15.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
2"
PRO
011
035410
101SD0P
Reducer
011-D-0028
-
-
P
25
LUBE OIL
Liquid
840
7.00
70.00
-
-
10.00
120.00
-
H
15.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
3/4"
PRO
011
035410
101SD0P
2"-PRO-011035410-101SD0P-P
Blind flange
-
-
P
25
LUBE OIL
Liquid
840
7.00
70.00
-
-
10.00
120.00
-
H
15.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
1-1/2"
PRO
011
035411
101SD0P
2"-PRO-011035410-101SD0P-P
Reducer
-
-
P
25
LUBE OIL
Liquid
840
7.00
70.00
-
-
10.00
120.00
-
H
15.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
1-1/2"
PRO
011
035411
101SD0P
Reducer
Reducer
-
-
P
25
LUBE OIL
Liquid
840
7.00
70.00
-
-
10.00
120.00
-
H
15.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
2"
PRO
011
035411
101SD0P
Reducer
011-D-0028
-
-
P
25
LUBE OIL
Liquid
840
7.00
70.00
-
-
10.00
120.00
-
H
15.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
3"
PRO
011
035412
101SD0P
011-D-0028
Reducer
-
-
P
25
LUBE OIL
Liquid
840
0.00
70.00
-
-
0.00
120.00
-
H
0.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
3"
PRO
011
035412
101SD0P
3"-PRO-011035412-101SD0P-P
10A
-
-
P
25
LUBE OIL
Liquid
840
0.00
70.00
-
-
0.00
120.00
-
H
0.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
2-1/2"
PRO
011
035412
101SD0P
Reducer
011-G-0029-A
-
-
P
25
LUBE OIL
Liquid
840
0.00
70.00
-
-
0.00
120.00
-
H
0.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
2"
PRO
011
035413
101SD0P
011-PZV-0553
011-D-0028
-
-
P
25
LUBE OIL
Liquid
840
7.00
70.00
-
-
10.00
120.00
-
H
15.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
2"
PRO
011
035413
101SD0P
011-PZV-0552
2"-PRO-011035413-101SD0P-P
-
-
P
25
LUBE OIL
Liquid
840
7.00
70.00
-
-
10.00
120.00
-
H
15.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
3"
PRO
011
035414
101SD0P
011-D-0028
Reducer
-
-
P
25
LUBE OIL
Liquid
840
0.00
70.00
-
-
0.00
120.00
-
H
0.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
3"
PRO
011
035414
101SD0P
3"-PRO-011035414-101SD0P-P
10A
-
-
P
25
LUBE OIL
Liquid
840
0.00
70.00
-
-
0.00
120.00
-
H
0.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
2-1/2"
PRO
011
035414
101SD0P
Reducer
011-G-0029-B
-
-
P
25
LUBE OIL
Liquid
840
0.00
70.00
-
-
0.00
120.00
-
H
0.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
2"
PRO
011
035415
101SD0P
011-E-0043
2"-PRO-011035417-101SD0P-P
-
-
N
-
LUBE OIL
Liquid
840
7.00
70.00
-
-
10.00
120.00
-
H
15.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
2"
PRO
011
035416
101SD0P
011-G-0029-B
2"-PRO-011035417-101SD0P-P
-
-
P
25
LUBE OIL
Liquid
840
7.00
70.00
-
-
10.00
120.00
-
H
15.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
3/4"
PRO
011
035416
101SD0P
2"-PRO-011035416-101SD0P-P
011-PI-0555
-
-
P
25
LUBE OIL
Liquid
840
7.00
70.00
-
-
10.00
120.00
-
H
15.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
2"
PRO
011
035417
101SD0P
011-G-0029-A
2"-PRO-011035417-101SD0P-P
-
-
P
25
LUBE OIL
Liquid
840
7.00
70.00
-
-
10.00
120.00
-
H
15.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-380001
-1.00
250.00
100.00
if NOT insulated B or Q
Page 142 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480262
3/4"
PRO
011
035417
101SD0P
2"-PRO-011035417-101SD0P-P
011-PI-0556
-
-
P
25
LUBE OIL
Liquid
840
7.00
70.00
-
-
10.00
120.00
-
H
15.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
3/4"
PRO
011
035417
101SD0P
2"-PRO-011035417-101SD0P-P
Blind flange
-
-
P
25
LUBE OIL
Liquid
840
7.00
70.00
-
-
10.00
120.00
-
H
15.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
3/4"
PRO
011
035417
101SD0P
2"-PRO-011035417-101SD0P-P
Blind flange
-
-
P
25
LUBE OIL
Liquid
840
7.00
70.00
-
-
10.00
120.00
-
H
15.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
2"
PRO
011
035417
101SD0P
2"-PRO-011035417-101SD0P-P
1-1/2"-PRO-011035421-101SD0PP
-
-
P
25
LUBE OIL
Liquid
840
7.00
70.00
-
-
10.00
120.00
-
H
15.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
2"
PRO
011
035417
101SD0P
2"-PRO-011035417-101SD0P-P
2"-PRO-011035421-101SD0P-P
-
-
P
25
LUBE OIL
Liquid
840
7.00
70.00
-
-
10.00
120.00
-
H
15.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
1-1/2"
PRO
011
035418
101SD0P
2"-PRO-011035417-101SD0P-P
011-PZV-0553
-
-
P
25
LUBE OIL
Liquid
840
7.00
70.00
-
-
10.00
120.00
-
H
15.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
1-1/2"
PRO
011
035419
101SD0P
2"-PRO-011035416-101SD0P-P
011-PZV-0552
-
-
P
25
LUBE OIL
Liquid
840
7.00
70.00
-
-
10.00
120.00
-
H
15.00
NFS
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
2"
PRO
011
035420
101CS1P
2"-PRO-011035421-101SD0P-P
011-E-0043
-
-
N
-
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
2"
PRO
011
035421
101SD0P
2"-PRO-011035417-101SD0P-P
Reducer
-
-
P
25
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
D NO
E
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
3/4"
PRO
011
035421
101SD0P
2"-PRO-011035421-101SD0P-P
3/4"-OLW-011035309-101CS1PN
-
-
P
25
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
D NO
E
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
1"
PRO
011
035421
101SD0P
2"-PRO-011035421-101SD0P-P
011-PDT-0757
-
-
P
25
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
D NO
E
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
1-1/2"
PRO
011
035421
101SD0P
2"-PRO-011035417-101SD0P-P
2"-PRO-011035421-101SD0P-P
-
-
P
25
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
D NO
E
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
3"
PRO
011
035421
101SD0P
Reducer
011-S-0007-A
-
-
P
25
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
D NO
E
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
3"
PRO
011
035421
101SD0P
3"-PRO-011035421-101SD0P-P
011-S-0007-B
-
-
P
25
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
D NO
E
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
3/4"
PRO
011
035422
101SD0P
011-S-0007-A
011-S-0007-B
-
-
N
-
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
3/4"
PRO
011
035422
3/4"-OLW-011035303-101CS1P101SD0P 3/4"-PRO-011035422-101SD0P-N N
-
-
N
-
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
SA-JER-DS011-TRJR-480262
1"
PRO
011
035422
101SD0P 3/4"-PRO-011035422-101SD0P-N 3/4"-PRO-011035422-101SD0P-N
-
-
N
-
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480262
3/4"
PRO
011
035423
101SD0P
-
-
N
-
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480091
3/4"
PRO
011
035423
101SD0P
SA-JER-DS011-TRJR-480262
011-K-0001
-
-
N
-
LUBE OIL
Liquid
840
6.50
65.00
-
-
10.00
120.00
-
H
15.00
D
By Vendor
By Vendor
Y
N
N
N
N
N
By Vendor
-
SA-JER-DS011-TRJR-480136
2"
PRO
011
098001
103CS1P
2"-PRO-011033009-103CH2S-N
8"-SLP-011098003-103CS1P-S
S
41
H
25
RECOVERED LVGO
Liquid
846
6.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
4"-PRW-011042005-106CS2P-H
2"-PRO-011035409-101CS1P-N
SA-JER-DS011-TRJR-480003
4"
PRW
011
001001
106CS1P
SA-JER-DS011-TRJR-480100
12"
PRW
011
038001
101CS2P 12"-PRW-011038003-103CS2P-P
SA-JER-DS011-TRJR-480100
12"
PRW
011
038001
101CS2P
Reducer
SA-JER-DS011-TRJR-480100
8"
PRW
011
038001
101CS2P
8"-PRW-011038003-103CS2P-P
SA-JER-DS011-TRJR-480124
12"
PRW
011
038001
101CS2P
SA-JER-DS011-TRJR-480123
12"
PRW
011
038001
101CS2P
SA-JER-DS011-TRJR-480123
8"
PRW
011
038001
SA-JER-DS011-TRJR-480123
3/4"
PRW
011
SA-JER-DS011-TRJR-480123
8"
PRW
SA-JER-DS011-TRJR-480123
2"
PRW
SA-JER-DS011-TRJR-480123
12"
SA-JER-DS011-TRJR-480123
SA-JER-DS011-TRJR-480091
16"-CRU-011001005-106CS1P-H
-
-
H
40
WATER
Liquid
948.68
33.50
115.00
-
-
50.00
165.00
-
H
75.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480124
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
12"-PRW-011038001-101CS2P-P
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
Reducer
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480100
SA-JER-DS011-TRJR-480123
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
Reducer
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
101CS2P 12"-PRW-011038001-101CS2P-P 8"-PRW-011038001-101CS2P-P
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
038001
101CS2P 12"-PRW-011038001-101CS2P-P
Plug
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
011
038001
101CS2P
Reducer
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
011
038001
101CS2P 12"-PRW-011038001-101CS2P-P
Blind flange
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
PRW
011
038001
101CS2P
12"-PRW-011038001-101CS2P-P
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
12"
PRW
011
038001
101CS2P 12"-PRW-011038001-101CS2P-P
HEADER
-
-
P
25
WATER
Liquid
968.7
0.50
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
8"
PRW
011
038001
101CS2P
-
-
P
25
WATER
Liquid
968.7
0.50
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
12"
PRW
011
038001
101CS2P 12"-PRW-011038001-101CS2P-P
HEADER
-
-
P
25
WATER
Liquid
968.7
0.50
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
6"
PRW
011
038001
101CS2P 12"-PRW-011038001-101CS2P-P
011-A-0007-A/B/C/D/E/F
-
-
P
25
WATER
Liquid
968.7
0.50
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
6"
PRW
011
038001
101CS2P 12"-PRW-011038001-101CS2P-P
011-A-0007-E/F
-
-
P
25
WATER
Liquid
968.7
0.50
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
6"
PRW
011
038001
101CS2P 12"-PRW-011038001-101CS2P-P
011-A-0007-C/D
-
-
P
25
WATER
Liquid
968.7
0.50
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
6"
PRW
011
038001
101CS2P 12"-PRW-011038001-101CS2P-P
011-A-0007-C/D
-
-
P
25
WATER
Liquid
968.7
0.50
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
6"
PRW
011
038001
101CS2P 12"-PRW-011038001-101CS2P-P
011-A-0007-A/B
-
-
P
25
WATER
Liquid
968.7
0.50
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
6"
PRW
011
038001
101CS2P 12"-PRW-011038001-101CS2P-P
011-A-0007-E/F
-
-
P
25
WATER
Liquid
968.7
0.50
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480100
2"
PRW
011
038002
101CS2P
011-TZV-0005
AT GRADE
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
188.00
-
Visual Test
0.00
NFS
By Code
A or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 150ºC NOTE 10
SA-JER-DS011-TRJR-480100
14"
PRW
011
038003
103CS2P
011-E-0030-A
Reducer
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
23.10
150.00
-
H
34.65
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 150ºC
SA-JER-DS011-TRJR-480100
12"
PRW
011
038003
103CS2P
Reducer
Reducer
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
23.10
150.00
-
H
34.65
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 150ºC
SA-JER-DS011-TRJR-480100
8"
PRW
011
038003
103CS2P
Reducer
8"-PRW-011038001-101CS2P-P
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
23.10
150.00
-
H
34.65
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 150ºC
SA-JER-DS011-TRJR-480100
12"
PRW
011
038003
103CS2P 12"-PRW-011038003-103CS2P-P
Reducer
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
23.10
150.00
-
H
34.65
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 150ºC
SA-JER-DS011-TRJR-480100
3/4"
PRW
011
038003
103CS2P 12"-PRW-011038003-103CS2P-P
Plug
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
23.10
150.00
-
H
34.65
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 150ºC
Reducer
Reducer
8"-PRW-011038001-101CS2P-P 12"-PRW-011038001-101CS2P-P
SA-JER-DS011-TRJR-480100
8"
PRW
011
038003
103CS2P
Reducer
Reducer
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
23.10
150.00
-
H
34.65
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 150ºC
SA-JER-DS011-TRJR-480100
12"
PRW
011
038003
103CS2P
Reducer
12"-PRW-011038001-101CS2P-P
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
23.10
150.00
-
H
34.65
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 150ºC
SA-JER-DS011-TRJR-480100
12"
PRW
011
038004
103CS2P 12"-PRW-011052003-101CS2P-H
Reducer
-
-
H
40
WATER
Liquid
980.74
2.60
65.00
-
-
23.10
150.00
-
H
34.65
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 150ºC
SA-JER-DS011-TRJR-480100
3/4"
PRW
011
038004
103CS2P 12"-PRW-011038004-103CS2P-H
Plug
-
-
H
25
WATER
Liquid
980.74
2.60
65.00
-
-
23.10
150.00
-
H
34.65
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 150ºC
SA-JER-DS011-TRJR-480100
14"
PRW
011
038004
103CS2P
011-E-0030-B
-
-
H
40
WATER
Liquid
980.74
2.60
65.00
-
-
23.10
150.00
-
H
34.65
NFS
By Code
M or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480100
2"
PRW
011
038005
103CS2P 12"-PRW-011038003-103CS2P-P
Reducer
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
23.10
150.00
-
H
34.65
NFS
By Code
M or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480100
3/4"
PRW
011
038005
103CS2P
2"-PRW-011038005-103CS2P-P
Plug
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
23.10
150.00
-
H
34.65
NFS
By Code
M or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480100
1"
PRW
011
038005
103CS2P
Reducer
011-TZV-0005
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
23.10
150.00
-
H
34.65
NFS
By Code
M or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480100
-
PRW
011
038601
106CS2P
011-E-0030 A/B
TRIM
-
-
H
-
-
-
-
4.50
85.00
-
-
23.10
150.00
-
Visual Test
0.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
MAX. TEMPERATURE FOR THERMAL EXPANSION: 150ºC NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 150ºC NOTE 10 MAX. TEMPERATURE FOR THERMAL EXPANSION: 150ºC NOTE 10 -
SA-JER-DS011-TRJR-480107
6"
PRW
011
042001
106CS2P
011-E-0032-A
Reducer
-
-
H
50
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
3/4"
PRW
011
042001
106CS2P
6"-PRW-011042001-106CS2P-H
Blind flange
-
-
H
25
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
2"
PRW
011
042001
106CS2P
Reducer
2"-PRW-011042002-106CS2P-H
-
-
H
40
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
6"
PRW
011
042001
106CS2P
6"-PRW-011042001-106CS2P-H
Reducer
-
-
H
50
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
3"
PRW
011
042001
106CS2P
Reducer
Reducer
-
-
H
40
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
1/2"
PRW
011
042001
106CS2P
011-FE-0004
011-FT-0004
-
-
H
25
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
1/2"
PRW
011
042001
106CS2P
011-FE-0004
011-FT-0004
-
-
H
25
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
6"
PRW
011
042001
106CS2P
Reducer
6"-PRW-011042002-106CS2P-H
-
-
H
50
WATER
Liquid
947.78
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
3/4"
PRW
011
042001
106CS2P
6"-PRW-011042001-106CS2P-H
Blind flange
-
-
H
25
WATER
Liquid
947.78
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
6"
PRW
011
042001
106CS2P
6"-PRW-011042001-106CS2P-H
Reducer
-
-
H
50
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
6"
PRW
011
042002
106CS2P
6"-PRW-011042001-106CS2P-H
SA-JER-DS011-TRJR-480010
-
-
H
50
WATER
Liquid
947.78
14.90
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
6"
PRW
011
042002
106CS2P
Reducer
6"-PRW-011042002-106CS2P-H
-
-
H
50
WATER
Liquid
947.78
14.90
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
2"
PRW
011
042002
106CS2P
2"-PRW-011042001-106CS2P-H
Reducer
-
-
H
40
WATER
Liquid
947.78
14.90
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
6"
PRW
011
042002
106CS2P
SA-JER-DS011-TRJR-480107
6"-PRW-011042002-106CS2P-H
-
-
H
50
WATER
Liquid
947.78
14.90
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480010
6"
PRW
011
042002
106CS2P
6"-PRW-011042002-106CS2P-H
6"-BRN-011007002-106CS2P-H
-
-
H
50
WATER
Liquid
922
15.30
145.00
-
-
50.00
178.00
-
H
75.00
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
Reducer
Reducer
-
-
H
40
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
-
H
25
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
Reducer
MAX. TEMPERATURE FOR THERMAL EXPANSION: 150ºC
SA-JER-DS011-TRJR-480107
4"
PRW
011
042005
106CS2P
SA-JER-DS011-TRJR-480107
3/4"
PRW
011
042005
106CS2P
4"-PRW-011042005-106CS2P-H
Blind flange
-
WATER
Liquid
SA-JER-DS011-TRJR-480107
4"
PRW
011
042005
106CS2P
4"-PRW-011042005-106CS2P-H
Reducer
-
-
H
40
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
2"
PRW
011
042005
106CS2P
Reducer
2"-PRW-011042005-106CS2P-H
-
-
H
40
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
2"
PRW
011
042005
106CS2P
Reducer
Reducer
-
-
H
40
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
1/2"
PRW
011
042005
106CS2P
011-FE-0005
011-FT-0005
-
-
H
25
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
1/2"
PRW
011
042005
106CS2P
011-FE-0005
011-FT-0005
-
-
H
25
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
4"
PRW
011
042005
106CS2P
SA-JER-DS011-TRJR-480107
4"-PRW-011001001-106CS1P-H
-
-
H
40
WATER
Liquid
948.68
33.50
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480003
3/4"
PRW
011
042005
106CS2P
4"-PRW-011042005-106CS2P-H
Blind flange
-
-
H
25
WATER
Liquid
948.68
33.50
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
4"
PRW
011
042005
106CS2P
Reducer
4"-PRW-011042005-106CS2P-H
-
-
H
40
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
3/4"
PRW
011
042005
106CS2P
4"-PRW-011042005-106CS2P-H
Blind flange
-
-
H
25
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
4"
PRW
011
042005
106CS2P
4"-PRW-011042005-106CS2P-H
SA-JER-DS011-TRJR-480003
-
-
H
40
WATER
Liquid
948.9
33.50
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
2"
PRW
011
042005
106CS2P
2"-PRW-011042005-106CS2P-H
Reducer
-
-
H
40
WATER
Liquid
948.9
33.50
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
4"
PRW
011
042005
106CS2P
Reducer
4"-PRW-011042005-106CS2P-H
-
-
H
40
WATER
Liquid
948.9
33.50
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
6"
PRW
011
042006
106CS2P
6"-PRW-011042001-106CS2P-H
Reducer
-
-
H
50
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
2"
PRW
011
042006
106CS2P
Reducer
2"-PRW-011042006-106CS2P-H
-
-
H
40
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
3/4"
PRW
011
042006
106CS2P
6"-PRW-011042006-106CS2P-H
Blind flange
-
-
H
25
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
6"
PRW
011
042006
106CS2P
6"-PRW-011042006-106CS2P-H
Reducer
-
-
H
50
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
4"
PRW
011
042006
106CS2P
Reducer
Reducer
-
-
H
40
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
Page 143 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
(NOTE 3)
DOC. No.
DENSITY (kg/m3)
(NOTE 4)
PRESS. (BARG)
115.00
PRESS. (BARG) -
TEMP. (ºC) -
PRESS. (BARG) 49.80
TEMP. (ºC) 165.00
STRESS TEMP
(ºC) -
TEST CONDITIONS
MEDIUM (NOTE 5) H
PRESS. (BARG) 74.70
FLUID CATEGORY (ASME B.31.3)
05 14-MAY-2013
PWHT REQUIRED
(NOTE 6) NFS
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
1/2"
PRW
011
042006
106CS2P
011-FT-0060
-
-
H
25
WATER
Liquid
-
NOTE 6
SA-JER-DS011-TRJR-480107
1/2"
PRW
011
042006
106CS2P
011-FE-0060
011-FT-0060
-
-
H
25
WATER
Liquid
948.9
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
6"
PRW
011
042006
106CS2P
SA-JER-DS011-TRJR-480107
6"-CRU-011006002-106CS2P-H
-
-
H
50
WATER
Liquid
947.78
14.90
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480013
3/4"
PRW
011
042006
106CS2P
6"-PRW-011042006-106CS2P-H
Blind flange
-
-
H
25
WATER
Liquid
947.78
14.90
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
6"
PRW
011
042006
106CS2P
Reducer
6"-PRW-011042006-106CS2P-H
-
-
H
50
WATER
Liquid
947.78
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
3/4"
PRW
011
042006
106CS2P
6"-PRW-011042006-106CS2P-H
Blind flange
-
-
H
25
WATER
Liquid
947.78
37.80
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
6"
PRW
011
042006
106CS2P
6"-PRW-011042006-106CS2P-H
SA-JER-DS011-TRJR-480013
-
-
H
50
WATER
Liquid
947.78
14.90
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
6"
PRW
011
042006
106CS2P
Reducer
6"-PRW-011042006-106CS2P-H
-
-
H
50
WATER
Liquid
947.78
14.90
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
2"
PRW
011
042006
106CS2P
Reducer
-
-
H
40
WATER
Liquid
947.78
14.90
115.00
-
-
49.80
165.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
2"-PRW-011042006-106CS2P-H
37.80
TEMP. (ºC)
DESIGN CONDITIONS
ALTERNATE CONDITIONS
Rev Date:
SA-JER-DS011-TRJR-480107
011-FE-0060
948.9
OPERATING CONDITIONS
SA-JER-DS011-TRJR-380001
By Code
M or Q
N
N
N
N
N
N
if insulated M or Q SA-JER-DS011-TRJR-480107
-
PRW
011
042601
106CS2P
011-E-0032-A/B
TRIM
-
-
H
-
-
-
-
38.80
115.00
-
-
49.80
165.00
-
Visual Test
0.00
D
By Code
SA-JER-DS011-TRJR-480107
2"
PRW
011
042601
106CS2P
011-E-0032-B
011-TW-0335
-
-
H
40
-
-
-
38.80
115.00
-
-
49.80
165.00
-
H
74.70
D
By Code
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
N
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150 ºC.
N
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150 ºC.
SA-JER-DS011-TRJR-480112
2"
PRW
011
043001
101CS1P
011-D-0007
2"-LFL-011043301-101CH2F-N
-
-
N
-
NITROGEN
Gas
-
1.00
50.00
-
-
3.50
150.00
-
H
5.25
D
By Code
A or Q
N
N
N
N
N
N
-
CHANGE: 43ºC TO 150ºC
SA-JER-DS011-TRJR-480112
12"
PRW
011
043002
101CS1P
Reducer
011-SP-0035
-
-
N
-
WATER
Liquid
991
1.00
43.00
-
-
3.50
150.00
-
H
5.25
D
By Code
A or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 155 ºC. MAX TEMPERATURE FOR OTHER CASES: 150 ºC. NOTE 10.
SA-JER-DS011-TRJR-480112
12"
PRW
011
043002
101CS1P
011-SP-0035
Reducer
-
-
N
-
WATER
Liquid
991
1.00
43.00
-
-
3.50
150.00
-
H
5.25
D
By Code
A or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 155 ºC. MAX TEMPERATURE FOR OTHER CASES: 150 ºC. NOTE 10.
SA-JER-DS011-TRJR-480112
6"
PRW
011
043002
101CS1P
Reducer
011-PZV-0049
-
-
N
-
WATER
Liquid
991
1.00
43.00
-
-
3.50
150.00
-
H
5.25
D
By Code
A or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 155 ºC. MAX TEMPERATURE FOR OTHER CASES: 150 ºC. NOTE 10.
SA-JER-DS011-TRJR-480112
12"
PRW
011
043002
101CS1P 12"-PRW-011043002-101CS1P-N
011-SP-0035
-
-
N
-
WATER
Liquid
991
1.00
43.00
-
-
3.50
150.00
-
H
5.25
D
By Code
A or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 155 ºC. MAX TEMPERATURE FOR OTHER CASES: 150 ºC. NOTE 10.
SA-JER-DS011-TRJR-480112
12"
PRW
011
043002
101CS1P
011-SP-0035
Reducer
-
-
N
-
WATER
Liquid
991
1.00
43.00
-
-
3.50
150.00
-
H
5.25
D
By Code
A or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 155 ºC. MAX TEMPERATURE FOR OTHER CASES: 150 ºC. NOTE 10. MAX.TEMPERATURE DURING FIRE SCENARIO: 155 ºC. MAX TEMPERATURE FOR OTHER CASES: 150 ºC. NOTE 10.
SA-JER-DS011-TRJR-480112
6"
PRW
011
043002
101CS1P
Reducer
011-PZV-0050
-
-
N
-
WATER
Liquid
991
1.00
43.00
-
-
3.50
150.00
-
H
5.25
D
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480112
10"
PRW
011
043002
101CS1P
011-D-0007
Reducer
-
-
N
-
WATER
Liquid
991
1.00
43.00
-
-
3.50
150.00
-
H
5.25
D
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480112
3/4"
PRW
011
043002
101CS1P 12"-PRW-011043002-101CS1P-N 3/4"-LFL-011043302-101CH2F-N
-
-
N
-
WATER
Liquid
991
1.00
43.00
-
-
3.50
150.00
-
H
5.25
D
By Code
A or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 155 ºC. MAX TEMPERATURE FOR OTHER CASES: 150 ºC. NOTE 10.
SA-JER-DS011-TRJR-480112
3/4"
PRW
011
043002
101CS1P 12"-PRW-011043002-101CS1P-N 3/4"-LFL-011043302-101CH2F-N
-
-
N
-
WATER
Liquid
991
1.00
43.00
-
-
3.50
150.00
-
H
5.25
D
By Code
A or Q
N
N
N
N
N
N
-
MAX.TEMPERATURE DURING FIRE SCENARIO: 155 ºC. MAX TEMPERATURE FOR OTHER CASES: 150 ºC. NOTE 10.
SA-JER-DS011-TRJR-480112
8"
PRW
011
043003
101CS2P
011-D-0007
SA-JER-DS011-TRJR-480111
-
-
P
25
WATER
Liquid
991
1.20
43.00
-
-
4.20
150.00
-
H
6.30
D
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
8"
PRW
011
043003
101CS2P
SA-JER-DS011-TRJR-480112
8"-PRW-011043005-106CS2P-P
-
-
P
25
WATER
Liquid
991
1.20
43.00
-
-
4.20
150.00
-
H
6.30
D
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
8"
PRW
011
043003
101CS2P
8"-PRW-011043003-101CS2P-P
8"-PRW-011043004-106CS2P-P
-
-
P
25
WATER
Liquid
991
1.20
43.00
-
-
4.20
150.00
-
H
6.30
D
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
8"
PRW
011
043004
106CS2P
8"-PRW-011043003-101CS2P-P
Reducer
-
-
P
25
WATER
Liquid
991
1.20
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
3/4"
PRW
011
043004
106CS2P
8"-PRW-011043004-106CS2P-P
UC
-
-
P
25
WATER
Liquid
991
1.20
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
3/4"
PRW
011
043004
106CS2P
8"-PRW-011043004-106CS2P-P
011-PI-0263
-
-
P
25
WATER
Liquid
991
1.20
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
6"
PRW
011
043004
106CS2P
Reducer
011-G-0021-A
-
-
P
25
WATER
Liquid
991
1.20
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480244
3/4"
PRW
011
043004
106CS2P
SA-JER-DS011-TRJR-480111
2"-OLW-011171307-101CS1P-N
-
-
P
25
WATER
Liquid
991
0.00
27.00
-
-
0.00
60.00
-
H
0.00
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
8"
PRW
011
043005
106CS2P
8"-PRW-011043003-101CS2P-P
Reducer
-
-
P
25
WATER
Liquid
991
1.20
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
3/4"
PRW
011
043005
106CS2P
8"-PRW-011043005-106CS2P-P
011-PI-0286
-
-
P
25
WATER
Liquid
991
1.20
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
3/4"
PRW
011
043005
106CS2P
8"-PRW-011043005-106CS2P-P
UC
-
-
P
25
WATER
Liquid
991
1.20
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
6"
PRW
011
043005
106CS2P
Reducer
011-G-0021-B
-
-
P
25
WATER
Liquid
991
1.20
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480244
3/4"
PRW
011
043005
106CS2P
SA-JER-DS011-TRJR-480111
2"-OLW-011171308-101CS1P-N
-
-
P
25
WATER
Liquid
991
0.00
27.00
-
-
0.00
60.00
-
H
0.00
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
3"
PRW
011
043006
106CS2P
011-G-0021-A
Reducer
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
6"
PRW
011
043006
106CS2P
Reducer
6"-PRW-011043006-106CS2P-P
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
1/2"
PRW
011
043006
106CS2P
011-FE-0180-A/B
011-FT-0180-B
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
1/2"
PRW
011
043006
106CS2P
011-FE-0180-A/B
011-FT-0180-B
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
1/2"
PRW
011
043006
106CS2P
011-FE-0180-A/B
011-FT-0180-A
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
1/2"
PRW
011
043006
106CS2P
011-FE-0180-A/B
011-FT-0180-A
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
3/4"
PRW
011
043006
106CS2P
6"-PRW-011043006-106CS2P-P
011-PI-0097
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480110
6"
PRW
011
043006
106CS2P
SA-JER-DS011-TRJR-480111
011-E-0024
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480110
3/4"
PRW
011
043006
106CS2P
6"-PRW-011043006-106CS2P-P
Blind flange
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
6"
PRW
011
043006
106CS2P
6"-PRW-011043006-106CS2P-P
SA-JER-DS011-TRJR-480110
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
2"
PRW
011
043006
106CS2P
011-AT-0018
6"-PRW-011043006-106CS2P-P
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
3"
PRW
011
043006
106CS2P
011-G-0021-B
Reducer
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
6"
PRW
011
043006
106CS2P
Reducer
6"-PRW-011043006-106CS2P-P
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
3/4"
PRW
011
043006
106CS2P
6"-PRW-011043006-106CS2P-P
011-PI-0096
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480111
6"
PRW
011
043006
106CS2P
6"-PRW-011043006-106CS2P-P
6"-PRW-011043006-106CS2P-P
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480110
6"
PRW
011
043007
106CS2P
011-E-0024
SA-JER-DS011-TRJR-480107
-
-
H
40
WATER
Liquid
986.2
38.30
57.40
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
6"
PRW
011
043007
106CS2P
SA-JER-DS011-TRJR-480110
011-E-0032-B
-
-
H
40
WATER
Liquid
986.2
38.30
57.40
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
1-1/2"
PRW
011
043007
106CS2P
6"-PRW-011043007-106CS2P-H
Blind flange
-
-
H
25
WATER
Liquid
986.2
38.30
57.40
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480107
2"
PRW
011
043007
106CS2P
6"-PRW-011043007-106CS2P-H
011-TT-0188
-
-
H
25
WATER
Liquid
986.2
38.30
57.40
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480112
2"
PRW
011
043008
101CS2P
011-D-0007
2"-OLW-011043302-101CS1P-N
-
-
P
25
WATER
Liquid
991
1.20
43.00
-
-
4.20
150.00
-
H
6.30
D
By Code
M
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480110
3/4"
PRW
011
043012
106CS2P
6"-PRW-011043006-106CS2P-P
011-SC-0014
-
-
N
-
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
A or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480273
1/2"
PRW
011
043012
106CS2P
SO
-
-
N
-
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
A or Q
Y
N
N
N
N
N
-
NOTE 6
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
NOTE 6
-
-
P
25
WATER
Liquid
993
37.70
43.00
-
-
49.80
150.00
-
H
74.70
NFS
By Code
M
N
N
N
N
N
N
-
-
-
-
P
25
WATER
Liquid
991
1.20
43.00
-
-
4.20
150.00
-
H
6.30
D
By Code
M
N
N
N
N
N
N
-
NOTE 6
Reducer
1-1/2"-OLW-011043304-101CS1PN 1-1/2"-PRW-011043014-106CS2PP 1-1/2"-PRW-011043014-106CS2PP 1-1/2"-PRW-011043014-106CS2PP 1-1/2"-OLW-011043303-101CS1PN 1-1/2"-PRW-011043015-106CS2PP 1-1/2"-PRW-011043015-106CS2PP 1-1/2"-PRW-011043015-106CS2PP
SA-JER-DS011-TRJR-480111
1-1/2"
PRW
011
043014
106CS2P
6"-PRW-011043006-106CS2P-P
SA-JER-DS011-TRJR-480111
1-1/2"
PRW
011
043014
106CS2P
8"-PRW-011043004-106CS2P-P
SA-JER-DS011-TRJR-480111
3/4"
PRW
011
043014
106CS2P
011-G-0021-A
SA-JER-DS011-TRJR-480111
3/4"
PRW
011
043014
106CS2P
011-G-0021-A
SA-JER-DS011-TRJR-480111
1-1/2"
PRW
011
043015
106CS2P
6"-PRW-011043006-106CS2P-P
SA-JER-DS011-TRJR-480111
1-1/2"
PRW
011
043015
106CS2P
8"-PRW-011043005-106CS2P-P
SA-JER-DS011-TRJR-480111
3/4"
PRW
011
043015
106CS2P
011-G-0021-B
SA-JER-DS011-TRJR-480111
3/4"
PRW
011
043015
106CS2P
011-G-0021-B
SA-JER-DS011-TRJR-480112
2"
PRW
011
043017
101CS2P
8"-PRW-011043003-101CS2P-P
2"-OLW-011043301-101CS1P-N
SA-JER-DS011-TRJR-480112
2"
PRW
011
043018
101CS2P
UC
011-D-0007
-
-
P
25
LP STEAM
Gas
-
1.00
50.00
-
-
3.50
150.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: 7 BARG+FV@290ºC.
SA-JER-DS011-TRJR-480112
3/4"
PRW
011
043018
101CS2P
2"-PRW-011043018-101CS2P-P
Plug
-
-
P
25
LP STEAM
Gas
-
1.00
50.00
-
-
3.50
150.00
-
H
5.25
D
By Code
M
N
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: 7 BARG+FV@290ºC.
SA-JER-DS011-TRJR-480111
2"
PRW
011
043019
103CS2P
8"-PRW-011043003-101CS2P-P
Flange
-
-
P
25
WATER
Liquid
993
1.20
43.00
-
-
4.20
150.00
-
H
6.30
NFS
By Code
M
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150 ºC.
N
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150 ºC.
if insulated M or Q SA-JER-DS011-TRJR-480112
-
PRW
011
043601
101CS1P
011-D-0007
TRIM
-
-
P
-
-
-
-
1.00
50.00
-
-
3.50
150.00
-
Visual Test
0.00
D
By Code
SA-JER-DS011-TRJR-480112
-
PRW
011
043602
103CS1P
011-D-0007
TRIM
-
-
P
-
-
-
-
1.00
50.00
-
-
3.50
150.00
-
Visual Test
0.00
D
By Code
SA-JER-DS011-TRJR-380001
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
Page 144 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7) if insulated M or Q N
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150 ºC.
N
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150 ºC.
N
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150 ºC.
N
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150 ºC.
N
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150 ºC.
N
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150 ºC.
N
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150 ºC.
N
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150 ºC.
N
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150 ºC.
N
N
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 BARA (HALF VACUUM) @ 150 ºC.
M or Q
N
N
N
N
N
N
-
M or Q
N
N
N
N
N
N
-
By Code
M or Q
N
N
N
N
N
N
-
By Code
M or Q
N
N
N
N
N
N
-
TEST PACKAGE TESTED H AT 9,00BARG
D
By Code
M or Q
N
N
N
N
N
N
-
-
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
1.00
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
H
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
-
H
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
-
H
40
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
-
-
H
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
2"-OLW-011171325-101CS1P-N
-
-
P
25
WATER
Liquid
980.74
0.00
27.00
-
-
0.00
60.00
-
H
0.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480248
-
-
P
25
WATER
Liquid
980.74
0.00
27.00
-
-
0.00
60.00
-
H
0.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
101CS2P 12"-PRW-011052003-101CS2P-H
Reducer
-
-
P
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
052004
101CS2P 12"-PRW-011052004-101CS2P-P
Plug
-
-
P
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
011
052004
101CS2P 12"-PRW-011052004-101CS2P-P
Reducer
-
-
P
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
011
052004
101CS2P
Reducer
6"-PRW-011052004-101CS2P-P
-
-
P
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
PRW
011
052004
101CS2P
Reducer
Reducer
-
-
P
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
12"
PRW
011
052004
101CS2P
Reducer
12"-PRW-011052004-101CS2P-P
-
-
P
25
WATER
Liquid
980.7
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
12"
PRW
011
052004
101CS2P 12"-PRW-011052004-101CS2P-P 12"-PRW-011038001-101CS2P-P
-
-
P
25
WATER
Liquid
980.7
2.04
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
12"
PRW
011
052004
101CS2P
Reducer
12"-PRW-011052004-101CS2P-P
-
-
P
25
WATER
Liquid
980.7
2.04
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
6"
PRW
011
052004
101CS2P
6"-PRW-011052004-101CS2P-P
Reducer
-
-
P
25
WATER
Liquid
980.7
2.04
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
011-D-0010
OLW
-
-
N
-
WATER
Liquid
968.6
0.00
27.00
-
-
3.50
150.00
-
Visual Test
0.00
D
By Code
A or Q
N
N
N
N
N
N
-
-
-
P
25
968.65
0.83
85.00
-
-
3.50
150.00
-
H
5.25
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
2"
PRW
011
043602
103CS1P
011-D-0007
011-PT-0311
-
-
P
25
-
-
-
1.00
50.00
-
-
3.50
150.00
-
H
5.25
D
By Code
SA-JER-DS011-TRJR-480112
6"
PRW
011
043602
103CS1P
011-D-0007
Blind flange
-
-
P
25
-
-
-
1.00
50.00
-
-
3.50
150.00
-
H
5.25
D
By Code
SA-JER-DS011-TRJR-480112
2"
PRW
011
043602
103CS1P
General inline element
011-PI-0310
-
-
P
25
-
-
-
1.00
50.00
-
-
3.50
150.00
-
H
5.25
D
By Code
SA-JER-DS011-TRJR-480112
-
PRW
011
043603
103CS2P
011-D-0007
TRIM
-
-
P
-
-
-
-
1.00
50.00
-
-
3.50
150.00
-
Visual Test
0.00
D
By Code
SA-JER-DS011-TRJR-480112
2"
PRW
011
043603
103CS2P
011-D-0007
011-LT-0069
-
-
P
25
-
-
-
1.00
50.00
-
-
3.50
150.00
-
H
5.25
D
By Code
SA-JER-DS011-TRJR-480112
2"
PRW
011
043603
103CS2P
011-D-0007
011-LT-0067
-
-
P
25
-
-
-
1.00
50.00
-
-
3.50
150.00
-
H
5.25
D
By Code
SA-JER-DS011-TRJR-480112
2"
PRW
011
043603
103CS2P
011-D-0007
011-LT-0069
-
-
P
25
-
-
-
1.00
50.00
-
-
3.50
150.00
-
H
5.25
D
By Code
SA-JER-DS011-TRJR-480112
2"
PRW
011
043603
103CS2P
011-D-0007
011-LG-0068
-
-
P
25
-
-
-
1.00
50.00
-
-
3.50
150.00
-
H
5.25
D
By Code
SA-JER-DS011-TRJR-480112
2"
PRW
011
043603
103CS2P
011-D-0007
011-LG-0068
-
-
P
25
-
-
-
1.00
50.00
-
-
3.50
150.00
-
H
5.25
D
By Code
SA-JER-DS011-TRJR-480112
2"
PRW
011
043603
103CS2P
011-D-0007
011-LT-0067
-
-
P
25
-
-
-
1.00
50.00
-
-
3.50
150.00
-
H
5.25
D
By Code
SA-JER-DS011-TRJR-480122
10"
PRW
011
052001
101CS2P
011-D-0010
10"-PRW-011052001-101CS2P-P
-
-
P
25
WATER
Liquid
968.65
0.83
85.00
-
-
3.50
150.00
-
H
5.25
D
By Code
SA-JER-DS011-TRJR-480122
2"
PRW
011
052001
101CS2P
2"-BFW-011052001-101CS1P-H
Insul Brk
-
-
P
25
WATER
Liquid
968.65
0.83
85.00
-
-
3.50
150.00
-
H
5.25
D
By Code
SA-JER-DS011-TRJR-480122
10"
PRW
011
052001
101CS2P 10"-PRW-011052001-101CS2P-P
SA-JER-DS011-TRJR-480123
-
-
P
25
WATER
Liquid
968.65
0.83
85.00
-
-
3.50
150.00
-
H
5.25
D
SA-JER-DS011-TRJR-480123
10"
PRW
011
052001
101CS2P
SA-JER-DS011-TRJR-480122
16"-PRW-011052002-101CS2P-H
-
-
P
25
WATER
Liquid
968.65
0.83
85.00
-
-
3.50
150.00
-
H
5.25
D
SA-JER-DS011-TRJR-480123
6"
PRW
011
052002
101CS2P
011-A-0007-A/B
12"-PRW-011052002-101CS2P-H
-
-
H
40
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
-
H
9.00
SA-JER-DS011-TRJR-480123
6"
PRW
011
052002
101CS2P
011-A-0007-C/D
12"-PRW-011052002-101CS2P-H
-
-
H
40
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
-
H
SA-JER-DS011-TRJR-480123
6"
PRW
011
052002
101CS2P
011-A-0007-E/F
12"-PRW-011052002-101CS2P-H
-
-
H
40
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
-
SA-JER-DS011-TRJR-480123
6"
PRW
011
052002
101CS2P
011-A-0007-C/D
12"-PRW-011052002-101CS2P-H
-
-
H
40
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
SA-JER-DS011-TRJR-480123
6"
PRW
011
052002
101CS2P
011-A-0007-E/F
12"-PRW-011052002-101CS2P-H
-
-
H
40
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
SA-JER-DS011-TRJR-480123
6"
PRW
011
052002
101CS2P
011-A-0007-A/B
12"-PRW-011052002-101CS2P-H
-
-
H
40
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
SA-JER-DS011-TRJR-480123
12"
PRW
011
052002
101CS2P
HEADER
Reducer
-
-
H
40
WATER
Liquid
980.6
1.00
65.00
-
-
SA-JER-DS011-TRJR-480124
16"
PRW
011
052002
101CS2P
SA-JER-DS011-TRJR-480123
16"-PRW-011052013-101CS2P-H
-
-
H
40
WATER
Liquid
980.6
1.00
65.00
-
SA-JER-DS011-TRJR-480123
16"
PRW
011
052002
101CS2P
Reducer
SA-JER-DS011-TRJR-480124
-
-
H
40
WATER
Liquid
980.6
1.00
65.00
SA-JER-DS011-TRJR-480123
12"
PRW
011
052002
101CS2P
HEADER
Reducer
-
-
H
40
WATER
Liquid
980.6
1.00
SA-JER-DS011-TRJR-480123
16"
PRW
011
052002
101CS2P
Reducer
16"-PRW-011052002-101CS2P-H
-
-
H
40
WATER
Liquid
980.6
SA-JER-DS011-TRJR-480124
8"
PRW
011
052003
101CS2P
011-G-0022-A
Reducer
-
-
H
40
WATER
Liquid
980.74
SA-JER-DS011-TRJR-480124
12"
PRW
011
052003
101CS2P
Reducer
SA-JER-DS011-TRJR-480100
-
-
H
40
WATER
Liquid
SA-JER-DS011-TRJR-480124
1/2"
PRW
011
052003
101CS2P
011-FE-0073
011-FT-0073
-
-
H
25
WATER
SA-JER-DS011-TRJR-480124
3/4"
PRW
011
052003
101CS2P 12"-PRW-011052003-101CS2P-H
011-PI-0151
-
-
H
25
SA-JER-DS011-TRJR-480124
1/2"
PRW
011
052003
101CS2P
011-FE-0073
011-FT-0073
-
-
H
SA-JER-DS011-TRJR-480124
1/2"
PRW
011
052003
101CS2P
011-FE-0073
011-FT-0073
-
-
SA-JER-DS011-TRJR-480124
1/2"
PRW
011
052003
101CS2P
011-FE-0073
011-FT-0073
-
SA-JER-DS011-TRJR-480100
12"
PRW
011
052003
101CS2P
12"-PRW-011038004-103CS2P-H
-
SA-JER-DS011-TRJR-480124
3/4"
PRW
011
052003
101CS2P 12"-PRW-011052003-101CS2P-H
Insul Brk
SA-JER-DS011-TRJR-480248
3/4"
PRW
011
052003
101CS2P
SA-JER-DS011-TRJR-480124
SA-JER-DS011-TRJR-480124
3/4"
PRW
011
052003
101CS2P
Insul Brk
SA-JER-DS011-TRJR-480124
12"
PRW
011
052004
SA-JER-DS011-TRJR-480124
3/4"
PRW
011
SA-JER-DS011-TRJR-480124
12"
PRW
SA-JER-DS011-TRJR-480124
6"
PRW
SA-JER-DS011-TRJR-480124
8"
SA-JER-DS011-TRJR-480124
SA-JER-DS011-TRJR-480124
if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q if insulated M or Q if NOT insulated B or Q
BIDIRECTIONAL EQUALIZING LINE. TEST PACKAGE TESTED H AT 9,00BARG BIDIRECTIONAL EQUALIZING LINE. TEST PACKAGE TESTED H AT 9,00BARG BIDIRECTIONAL EQUALIZING LINE. TEST PACKAGE TESTED H AT 9,00BARG
SA-JER-DS011-TRJR-480122
6"
PRW
011
052006
101CS2P
SA-JER-DS011-TRJR-480122
3/4"
PRW
011
052009
101CS2P
011-LG-0109
Reducer
-
WATER
Liquid
SA-JER-DS011-TRJR-480122
2"
PRW
011
052009
101CS2P
Reducer
2"-OLW-011052302-101CS1P-N
-
-
P
25
WATER
Liquid
968.65
0.83
85.00
-
-
3.50
150.00
-
H
5.25
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
8"
PRW
011
052010
101CS2P 12"-PRW-011038001-101CS2P-P
Insul Brk
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
6"
PRW
011
052010
101CS2P
Reducer
Insul Brk
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
8"
PRW
011
052010
101CS2P
8"-PRW-011052010-101CS2P-P
Reducer
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
3/4"
PRW
011
052010
101CS2P
8"-PRW-011052010-101CS2P-P
Plug
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
3/4"
PRW
011
052010
101CS2P
8"-PRW-011052010-101CS2P-P
Plug
-
-
P
25
WATER
Liquid
968.7
2.04
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
8"
PRW
011
052010
101CS2P
Insul Brk
16"-PRW-011052002-101CS2P-H
-
-
H
40
WATER
Liquid
968.6
1.00
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
8"
PRW
011
052010
101CS2P
Reducer
8"-PRW-011052010-101CS2P-H
-
-
H
40
WATER
Liquid
968.6
1.00
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
6"
PRW
011
052010
101CS2P
Insul Brk
Reducer
-
-
H
40
WATER
Liquid
968.6
1.00
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
1-1/2"
PRW
011
052011
101CS2P
011-A-0007-A/B
Reducer
-
-
P
25
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
1-1/2"
PRW
011
052011
101CS2P
011-A-0007-C/D
-
-
P
25
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
1-1/2"
PRW
011
052011
101CS2P
011-A-0007-C/D
-
-
P
25
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
1-1/2"
PRW
011
052011
101CS2P
011-A-0007-E/F
-
-
P
25
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
1-1/2"
PRW
011
052011
101CS2P
011-A-0007-A/B
-
-
P
25
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
1-1/2"-PRW-011052011-101CS2PP 1-1/2"-PRW-011052011-101CS2PP 1-1/2"-PRW-011052011-101CS2PP 1-1/2"-PRW-011052011-101CS2PP
Page 145 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480123
1-1/2"
PRW
011
052011
101CS2P
011-A-0007-E/F
1-1/2"-PRW-011052011-101CS2PP
-
-
P
25
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480123
2"
PRW
011
052011
101CS2P
Reducer
2"-OLW-011052306-101CS1P-N
-
-
P
25
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
16"
PRW
011
052012
101CS2P 16"-PRW-011052002-101CS2P-H
Reducer
-
-
H
40
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
UC
-
-
H
25
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
011-PI-0287
-
-
H
25
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
011-G-0022-A
-
-
H
40
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
2"
PRW
011
052012
101CS2P 16"-PRW-011052012-101CS2P-H
SA-JER-DS011-TRJR-480124
3/4"
PRW
011
052012
101CS2P 16"-PRW-011052012-101CS2P-H
SA-JER-DS011-TRJR-480124
10"
PRW
011
052012
101CS2P
SA-JER-DS011-TRJR-480124
16"
PRW
011
052013
101CS2P 16"-PRW-011052002-101CS2P-H
Reducer
-
-
H
40
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
2"
PRW
011
052013
101CS2P 16"-PRW-011052013-101CS2P-H
UC
-
-
H
25
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
3/4"
PRW
011
052013
101CS2P 16"-PRW-011052013-101CS2P-H
011-PI-0288
-
-
H
25
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
10"
PRW
011
052013
101CS2P
Reducer
011-G-0022-B
-
-
H
40
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
8"
PRW
011
052014
101CS2P
011-G-0022-B
Reducer
-
-
H
40
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
12"
PRW
011
052014
101CS2P
Reducer
12"-PRW-011052003-101CS2P-H
-
-
H
40
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
3/4"
PRW
011
052014
101CS2P 12"-PRW-011052014-101CS2P-H
011-PI-0152
-
-
H
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480248
3/4"
PRW
011
052014
101CS2P
2"-OLW-011171326-101CS1P-N
-
-
P
25
WATER
Liquid
980.74
0.00
27.00
-
-
0.00
60.00
-
H
0.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
3/4"
PRW
011
052014
101CS2P 12"-PRW-011052014-101CS2P-H
Insul Brk
-
-
H
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
3/4"
PRW
011
052014
101CS2P
SA-JER-DS011-TRJR-480248
-
-
P
25
WATER
Liquid
980.74
0.00
27.00
-
-
0.00
60.00
-
H
0.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
2"
PRW
011
052015
101CS2P 12"-PRW-011052003-101CS2P-H 2"-PRW-011052015-101CS2P-P
-
-
P
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
2"
PRW
011
052015
101CS2P
2"-OLW-011052303-101CS1P-N
-
-
P
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
2"
PRW
011
052015
101CS2P 16"-PRW-011052012-101CS2P-H
Insul Brk
-
-
H
25
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
2"
PRW
011
052015
101CS2P
Insul Brk
2"-PRW-011052015-101CS2P-P
-
-
P
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
3/4"
PRW
011
052015
101CS2P
011-G-0022-A
Reducer
-
-
P
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
1"
PRW
011
052015
101CS2P
Reducer
2"-PRW-011052015-101CS2P-P
-
-
P
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
2"
PRW
011
052016
101CS2P 12"-PRW-011052014-101CS2P-H
Insul Brk
-
-
H
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
2"
PRW
011
052016
101CS2P
2"-OLW-011052304-101CS1P-N
-
-
P
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
2"
PRW
011
052016
101CS2P 16"-PRW-011052013-101CS2P-H
Insul Brk
-
-
H
25
WATER
Liquid
980.6
1.00
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
Reducer
SA-JER-DS011-TRJR-480124
Insul Brk
2"-PRW-011052015-101CS2P-P
Insul Brk
SA-JER-DS011-TRJR-480124
2"
PRW
011
052016
101CS2P
Insul Brk
2"-PRW-011052016-101CS2P-P
-
-
P
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
3/4"
PRW
011
052016
101CS2P
011-G-0022-B
Reducer
-
-
P
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480124
1"
PRW
011
052016
101CS2P
Reducer
2"-PRW-011052016-101CS2P-P
-
-
P
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480122
2"
PRW
011
052017
101CS2P
011-D-0010
2"-OLW-011052301-101CS1P-N
-
-
P
25
WATER
Liquid
968.65
0.83
85.00
-
-
3.50
150.00
-
H
5.25
D
By Code
M or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480122
2"
PRW
011
052018
101CS2P
UC
Insul Brk
-
-
N
-
WATER
Liquid
968.65
0.83
25.00
-
-
3.50
150.00
-
H
5.25
D
By Code
A or Q
N
N
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS: 7 barg + FV @ 290ºC.
Insul Brk
ALTERNATE DESIGN CONDITIONS: 7 barg + FV @ 290ºC.
SA-JER-DS011-TRJR-480122
2"
PRW
011
052018
101CS2P
SA-JER-DS011-TRJR-480124
3/4"
PRW
011
052019
101CS2P 12"-PRW-011052004-101CS2P-P
SA-JER-DS011-TRJR-480274
3/4"
PRW
011
052019
101CS2P
12"-WAT-011052004-101CS2P-P
SA-JER-DS011-TRJR-480274
3/4"
PRW
011
052020
101CS2P
3/4"-PRW-011200001-101CH2S12"-WAT-011052004-101CS2P-P N
SA-JER-DS011-TRJR-480124
3/4"
PRW
011
052020
101CS2P
011-SC-0063
011-D-0010
-
-
P
25
WATER
Liquid
968.65
0.83
85.00
-
-
3.50
150.00
-
H
5.25
D
By Code
A or Q
N
N
N
N
N
N
-
011-SC-0063
-
-
P
25
WATER
Liquid
980.74
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
SAMPLE COOLER
-
-
P
25
WATER
Liquid
980.7
4.40
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
-
P
25
WATER
Liquid
980.7
2.04
65.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
-
-
P
25
WATER
Liquid
980.7
2.04
85.00
-
-
6.00
150.00
-
H
9.00
D
By Code
M or Q
N
N
N
N
N
N
-
THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE.NOTE 6. THIS LINE IS ALREADY DRAWN IN PROCESS/UTILITY DIAGRAMS.IT IS REPRESENTED IN THIS DIAGRAM ONLY AS REFERENCE.NOTE 6. -
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
N
N
N
N
N
N
-
-
-
12"-PRW-011052004-101CS2P-P
-
if insulated M or Q SA-JER-DS011-TRJR-480122
-
PRW
011
052601
101CS2P
011-D-0010
TRIM
-
-
P
-
-
-
-
0.00
85.00
-
-
3.50
150.00
-
Visual Test
0.00
D
By Code
SA-JER-DS011-TRJR-480122
2"
PRW
011
052601
101CS2P
011-D-0010
011-LT-0108
-
-
P
25
-
-
-
0.00
85.00
-
-
3.50
150.00
-
H
5.25
D
By Code
SA-JER-DS011-TRJR-480122
-
PRW
011
052602
103CS2P
011-D-0010
TRIM
-
-
P
-
-
-
-
0.00
85.00
-
-
3.50
150.00
-
Visual Test
0.00
D
By Code
SA-JER-DS011-TRJR-480122
2"
PRW
011
052602
103CS2P
011-D-0010
011-LT-0108
-
-
P
25
-
-
-
0.00
85.00
-
-
3.50
150.00
-
H
5.25
D
By Code
SA-JER-DS011-TRJR-480274
3/4"
PRW
011
200001
101CH2S
-
-
N
-
980.7
2.04
65.00
-
-
6.00
150.00
-
H
9.00
D
YES
if NOT insulated A or Q if insulated M or Q if NOT insulated A or Q if insulated M or Q if NOT insulated A or Q
SAMPLE COOLER
Reducer
N
-
SA-JER-DS011-TRJR-480274
4"
PRW
011
200001
101CH2S
Reducer
Reducer
-
-
N
-
WATER
Liquid
980.7
2.04
65.00
-
-
6.00
150.00
-
H
9.00
D
YES
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480274
3/4"
PRW
011
200001
101CH2S
Reducer
SO
-
-
N
-
WATER
Liquid
980.7
2.04
65.00
-
-
6.00
150.00
-
H
9.00
D
YES
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
PTG
011
045001
101CS1P
011-ZV-0032
ATM
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
55.00
-
Visual Test
0.00
NFS
By Code
A or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480215
2"
PTG
011
045301
101CS1P
2"-PTG-011075301-101CS1P-S
SA-JER-DS011-TRJR-480115
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480115
2"
PTG
011
045301
101CS1P
SA-JER-DS011-TRJR-480215
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
PTG
011
045301
101CS1P
2"-PTG-011045301-101CS1P-S
011-PDT-0142
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
PTG
011
045301
101CS1P
2"-PTG-011045301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
PTG
011
045301
101CS1P
2"-PTG-011045301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
2"
PTG
011
045301
101CS1P
2"-PTG-011045301-101CS1P-S
2"-PTG-011045301-101CS1P-S
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
PTG
011
045301
101CS1P
2"-PTG-011045301-101CS1P-S
011-PDT-0142
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
1"
PTG
011
045301
101CS1P
Reducer
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
2"
PTG
011
045301
101CS1P
Reducer
HEADER
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
PTG
011
045301
101CS1P
2"-PTG-011045301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
PTG
011
045301
101CS1P
2"-PTG-011045301-101CS1P-S
011-PT-0132
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
PTG
011
045301
101CS1P
2"-PTG-011045301-101CS1P-S
011-PT-0443
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
PTG
011
045301
101CS1P
2"-PTG-011045301-101CS1P-S
011-ZV-0032
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
PTG
011
045301
101CS1P
2"-PTG-011045301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
PTG
011
045301
101CS1P
2"-PTG-011045301-101CS1P-S
011-PT-0138
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
PTG
011
045301
101CS1P
2"-PTG-011045301-101CS1P-S
011-F-0001
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
PTG
011
045301
101CS1P
2"-PTG-011045301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
PTG
011
045301
101CS1P
2"-PTG-011045301-101CS1P-S
011-PT-0129
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
PTG
011
045301
101CS1P
2"-PTG-011045301-101CS1P-S
011-F-0001
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
PTG
011
045301
101CS1P
2"-PTG-011045301-101CS1P-S
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
PTG
011
045301
101CS1P
3/4"-PTG-011045301-101CS1P-S
011-PI-0125
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
1/2"
PTG
011
045301
101CS1P
Reducer
011-F-0001
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
2"
PTG
011
045301
101CS1P
2"-PTG-011045301-101CS1P-S
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
3/4"
PTG
011
045301
101CS1P
2"-PTG-011045301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480115
1"
PTG
011
045301
101CS1P
Reducer
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
Reducer
2"-PTG-011045301-101CS1P-S
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
20.5
H
25
-
5.00
28.60
-
-
8.50
80.00
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
WATER
Liquid
if NOT insulated A or Q if insulated M or Q
A or Q
N
N
N
N
N
-
SA-JER-DS011-TRJR-480115
2"
PTG
011
045301
101CS1P
SA-JER-DS011-TRJR-480115
3/4"
PTG
011
045301
101CS1P
2"-PTG-011045301-101CS1P-S
Plug
S
PILOT GAS
Gas
SA-JER-DS011-TRJR-480116
3/4"
PTG
011
046001
101CS1P
011-ZV-0052
ATM
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
55.00
-
Visual Test
0.00
NFS
By Code
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480215
2"
PTG
011
046301
101CS1P
2"-PTG-011075301-101CS1P-S
SA-JER-DS011-TRJR-480116
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480116
2"
PTG
011
046301
101CS1P
SA-JER-DS011-TRJR-480215
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
PTG
011
046301
101CS1P
2"-PTG-011046301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
PTG
011
046301
101CS1P
2"-PTG-011046301-101CS1P-S
011-PDT-0197
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
PTG
011
046301
101CS1P
2"-PTG-011046301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
PTG
011
046301
101CS1P
2"-PTG-011046301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
2"
PTG
011
046301
101CS1P
2"-PTG-011046301-101CS1P-S
2"-PTG-011046301-101CS1P-S
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
Page 146 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480116
3/4"
PTG
011
046301
101CS1P
2"-PTG-011046301-101CS1P-S
011-PDT-0197
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
2"
PTG
011
046301
101CS1P
2"-PTG-011046301-101CS1P-S
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
1"
PTG
011
046301
101CS1P
Reducer
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
PTG
011
046301
101CS1P
2"-PTG-011046301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
PTG
011
046301
101CS1P
2"-PTG-011046301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
1"
PTG
011
046301
101CS1P
Reducer
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
2"
PTG
011
046301
101CS1P
Reducer
2"-PTG-011046301-101CS1P-S
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
Reducer
Header
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
20.5
H
25
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
2"
PTG
011
046301
101CS1P
SA-JER-DS011-TRJR-480116
3/4"
PTG
011
046301
101CS1P
2"-PTG-011046301-101CS1P-S
011-F-0001
S
PILOT GAS
Gas
SA-JER-DS011-TRJR-480116
3/4"
PTG
011
046301
101CS1P
2"-PTG-011046301-101CS1P-S
011-PT-0393
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
PTG
011
046301
101CS1P
2"-PTG-011046301-101CS1P-S
011-PT-0191
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
PTG
011
046301
101CS1P
2"-PTG-011046301-101CS1P-S
011-F-0001
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
PTG
011
046301
101CS1P
2"-PTG-011046301-101CS1P-S
011-ZV-0052
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
PTG
011
046301
101CS1P
2"-PTG-011046301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
PTG
011
046301
101CS1P
2"-PTG-011046301-101CS1P-S
011-PT-0912
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
PTG
011
046301
101CS1P
2"-PTG-011046301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
PTG
011
046301
101CS1P
2"-PTG-011046301-101CS1P-S
011-PI-0188
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
PTG
011
046301
101CS1P
2"-PTG-011046301-101CS1P-S
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
3/4"
PTG
011
046301
101CS1P
3/4"-PTG-011046301-101CS1P-S
011-PI-0184
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480116
1/2"
PTG
011
046301
101CS1P
Reducer
011-F-0001
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
PTG
011
048001
101CS1P
011-ZV-0060
ATM
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
55.00
-
Visual Test
0.00
NFS
By Code
A or Q
Y
N
N
N
N
N
-
NOTE 6
2"-PTG-011075301-101CS1P-S
SA-JER-DS011-TRJR-480118
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480118
2"
PTG
011
048301
101CS1P
SA-JER-DS011-TRJR-480215
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
PTG
011
048301
101CS1P
2"-PTG-011048301-101CS1P-S
011-PDT-0215
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
2"
PTG
011
048301
101CS1P
2"-PTG-011048301-101CS1P-S
2"-PTG-011048301-101CS1P-S
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
PTG
011
048301
101CS1P
2"-PTG-011048301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
PTG
011
048301
101CS1P
2"-PTG-011048301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
PTG
011
048301
101CS1P
2"-PTG-011048301-101CS1P-S
011-PDT-0215
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
1"
PTG
011
048301
101CS1P
Reducer
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480215
2"
PTG
011
048301
101CS1P
S
20.5
H
25
PILOT GAS
SA-JER-DS011-TRJR-480118
2"
PTG
011
048301
101CS1P
Reducer
HEADER
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
PTG
011
048301
101CS1P
2"-PTG-011048301-101CS1P-S
011-PT-0400
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
PTG
011
048301
101CS1P
2"-PTG-011048301-101CS1P-S
011-F-0002
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
PTG
011
048301
101CS1P
2"-PTG-011048301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
PTG
011
048301
101CS1P
2"-PTG-011048301-101CS1P-S
011-PT-0210
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
PTG
011
048301
101CS1P
2"-PTG-011048301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
PTG
011
048301
101CS1P
2"-PTG-011048301-101CS1P-S
011-PI-0208
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
PTG
011
048301
101CS1P
2"-PTG-011048301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
PTG
011
048301
101CS1P
2"-PTG-011048301-101CS1P-S
011-PT-0219
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
PTG
011
048301
101CS1P
2"-PTG-011048301-101CS1P-S
011-ZV-0060
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
PTG
011
048301
101CS1P
2"-PTG-011048301-101CS1P-S
011-F-0002
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
PTG
011
048301
101CS1P
2"-PTG-011048301-101CS1P-S
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
PTG
011
048301
101CS1P
3/4"-PTG-011048301-101CS1P-S
011-PI-0204
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
1/2"
PTG
011
048301
101CS1P
Reducer
011-F-0002
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
2"
PTG
011
048302
101CS1P
2"-PTG-011048301-101CS1P-S
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
PTG
011
048302
101CS1P
2"-PTG-011048302-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
1"
PTG
011
048302
101CS1P
Reducer
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
2"
PTG
011
048302
101CS1P
Reducer
2"-PTG-011048301-101CS1P-S
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480118
3/4"
PTG
011
048302
101CS1P
2"-PTG-011048302-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
3/4"
PTG
011
049001
101CS1P
011-ZV-0068
ATM
-
-
N
-
AIR
Gas
-
0.00
27.00
-
-
0.00
55.00
-
Visual Test
0.00
NFS
By Code
A or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
2"
PTG
011
049002
101CS1P
2"-PTG-011049301-101CS1P-S
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
3/4"
PTG
011
049002
101CS1P
2"-PTG-011049002-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
1"
PTG
011
049002
101CS1P
Reducer
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
2"
PTG
011
049002
101CS1P
Reducer
2"-PTG-011049301-101CS1P-S
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480119
3/4"
PTG
011
049002
101CS1P
2"-PTG-011049002-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480215
2"
PTG
011
049301
101CS1P
2"-PTG-011075301-101CS1P-S
SA-JER-DS011-TRJR-480119
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
2"
PTG
011
049301
101CS1P
SA-JER-DS011-TRJR-480215
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
3/4"
PTG
011
049301
101CS1P
2"-PTG-011049301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
3/4"
PTG
011
049301
101CS1P
2"-PTG-011049301-101CS1P-S
011-PDT-0242
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
3/4"
PTG
011
049301
101CS1P
2"-PTG-011049301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
2"
PTG
011
049301
101CS1P
2"-PTG-011049301-101CS1P-S
2"-PTG-011049301-101CS1P-S
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
3/4"
PTG
011
049301
101CS1P
2"-PTG-011049301-101CS1P-S
011-PDT-0242
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
1"
PTG
011
049301
101CS1P
Reducer
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
2"
PTG
011
049301
101CS1P
Reducer
HEADER
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
3/4"
PTG
011
049301
101CS1P
2"-PTG-011049301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
3/4"
PTG
011
049301
101CS1P
2"-PTG-011049301-101CS1P-S
011-PT-0403
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
3/4"
PTG
011
049301
101CS1P
2"-PTG-011049301-101CS1P-S
011-F-0002
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
3/4"
PTG
011
049301
101CS1P
2"-PTG-011049301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
3/4"
PTG
011
049301
101CS1P
2"-PTG-011049301-101CS1P-S
011-PT-0226
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
3/4"
PTG
011
049301
101CS1P
2"-PTG-011049301-101CS1P-S
011-ZV-0068
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
3/4"
PTG
011
049301
101CS1P
2"-PTG-011049301-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
3/4"
PTG
011
049301
101CS1P
2"-PTG-011049301-101CS1P-S
011-PT-0225
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
3/4"
PTG
011
049301
101CS1P
2"-PTG-011049301-101CS1P-S
011-PI-0224
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
3/4"
PTG
011
049301
101CS1P
2"-PTG-011049301-101CS1P-S
011-F-0002
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
3/4"
PTG
011
049301
101CS1P
2"-PTG-011049301-101CS1P-S
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
3/4"
PTG
011
049301
101CS1P
3/4"-PTG-011049301-101CS1P-S
011-PI-0241
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480119
1/2"
PTG
011
049301
101CS1P
Reducer
011-F-0002
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480214
2"
PTG
011
075301
101CS1P
Reducer
SA-JER-DS011-TRJR-480215
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480215
2"
PTG
011
075301
101CS1P
SA-JER-DS011-TRJR-480214
HEADER
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
2"
PTG
011
075302
101CS1P
IP-1326 L
011-FE-0102
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
1/2"
PTG
011
075302
101CS1P
011-FT-0102
011-FE-0102
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
1/2"
PTG
011
075302
101CS1P
011-FT-0102
011-FE-0102
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
3/4"
PTG
011
075302
101CS1P
011-PI-0283
2"-PTG-011075302-101CS1P-S
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
2"
PTG
011
075302
101CS1P
011-FE-0102
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
4"
PTG
011
075302
101CS1P
Reducer
Reducer
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
2"
PTG
011
075302
101CS1P
4"-PTG-011075302-101CS1P-S
011-TT-0260
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
2"
PTG
011
075302
101CS1P
Reducer
10"-PTG-011075302-101CS1P-S
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
3/4"
PTG
011
075302
101CS1P
011-PT-0284
2"-PTG-011075302-101CS1P-S
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
10"
PTG
011
075302
101CS1P
2"-PTG-011075302-101CS1P-S
Reducer
S
20.5
H
40
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
2"
PTG
011
075303
101CS1P
2"-PTG-011075304-101CS1P-S
2"-LFL-011075307-101CH2F-S
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
3/4"
PTG
011
075303
101CS1P
2"-PTG-011075303-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
3/4"
PTG
011
075303
101CS1P
011-LG-0135
2"-PTG-011075303-101CS1P-S
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
Page 147 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480214
10"
PTG
011
075304
101CS1P
10"-PTG-011075302-101CS1P-S
HEADER
S
20.5
H
40
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
2"
PTG
011
075304
101CS1P
10"-PTG-011075304-101CS1P-S
011-LT-0136
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
2"
PTG
011
075304
101CS1P
10"-PTG-011075304-101CS1P-S
011-LG-0135
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
2"
PTG
011
075304
101CS1P
10"-PTG-011075304-101CS1P-S
011-LG-0135
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
2"
PTG
011
075304
101CS1P
10"-PTG-011075304-101CS1P-S
011-LT-0136
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
2"
PTG
011
075304
101CS1P
HEADER
2"-PTG-011075303-101CS1P-S
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
2"
PTG
011
075305
101CS1P
2"-PTG-011075302-101CS1P-S
2"-LFL-011075303-101CH2F-N
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
3/4"
PTG
011
075305
101CS1P
2"-PTG-011075305-101CS1P-S
UC
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
3/4"
PTG
011
075308
101CS1P
011-LG-0135
3/4"-LFL-011075307-101CH2F-S
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
8.50
155.00
-
H
12.75
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480214
3/4"
PTG
011
075308
101CS1P
3/4"-PTG-011075308-101CS1P-S
Plug
S
20.5
H
25
PILOT GAS
Gas
-
5.00
28.60
-
-
155.00
155.00
-
H
29.40
NFS
By Code
M or Q
Y
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
2"
RWA
011
040301
301CG0W 2"-RWA-011073303-301CG0W-N
SA-JER-DS011-TRJR-480105
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480105
2"
RWA
011
040301
301CG0W
2"-ACS-011040001-101CS1P-P
-
-
N
-
SERVICE WATER
Liquid
1000
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
2"
RWA
011
073301
301CG0W 2"-RWA-011073303-301CG0W-N
HEADER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
2"
RWA
011
073302
301FE0W
2"-RWA-011073303-301CG0W-N
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
NO
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
2"
RWA
011
073303
301CG0W 2"-RWA-011073302-301FE0W-N
HEADER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
2"
RWA
011
073303
301CG0W 2"-RWA-011073303-301CG0W-N
Plug
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
2"
RWA
011
073303
301CG0W 2"-RWA-011073303-301CG0W-N
Plug
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073304
301CG0W 2"-RWA-011073303-301CG0W-N
011-US-002
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
2"
RWA
011
073305
301CG0W 2"-RWA-011073303-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073305
301CG0W
011-US-003
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073306
301CG0W 2"-RWA-011073303-301CG0W-N
011-US-004
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073307
301CG0W 2"-RWA-011073303-301CG0W-N
011-US-006
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
2"
RWA
011
073308
301CG0W 2"-RWA-011073303-301CG0W-N
SA-JER-DS011-TRJR-480306
1"
RWA
011
073308
301CG0W
SA-JER-DS011-TRJR-480306
1"
RWA
011
073309
SA-JER-DS011-TRJR-480306
2"
RWA
011
SA-JER-DS011-TRJR-480306
1"
RWA
SA-JER-DS011-TRJR-480306
1"
SA-JER-DS011-TRJR-480306
SA-JER-DS011-TRJR-480209
IP-6126-S
Reducer
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
011-US-005
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
301CG0W 2"-RWA-011073303-301CG0W-N
011-US-008
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
073310
301CG0W 2"-RWA-011073303-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
011
073310
301CG0W
011-US-007
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
RWA
011
073311
301CG0W 2"-RWA-011073303-301CG0W-N
011-US-010
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
2"
RWA
011
073312
301CG0W 2"-RWA-011073303-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073312
301CG0W
011-US-009
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
2"
RWA
011
073313
301CG0W 2"-RWA-011073303-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073313
301CG0W
011-US-011
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073314
301CG0W 2"-RWA-011073344-301CG0W-N
011-US-037
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073315
301CG0W 2"-RWA-011073303-301CG0W-N
011-US-014
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073316
301CG0W 2"-RWA-011073303-301CG0W-N
011-US-013
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073317
301CG0W 2"-RWA-011073303-301CG0W-N
011-US-016
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073318
301CG0W 2"-RWA-011073303-301CG0W-N
011-US-015
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073319
301CG0W 2"-RWA-011073303-301CG0W-N
011-US-017
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
2"
RWA
011
073320
301CG0W 2"-RWA-011073303-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073320
301CG0W
011-US-018
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073321
301CG0W 2"-RWA-011073303-301CG0W-N
011-US-020
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073322
301CG0W 2"-RWA-011073303-301CG0W-N
011-US-019
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073323
301CG0W 2"-RWA-011073303-301CG0W-N
011-US-001
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073324
301CG0W 2"-RWA-011073320-301CG0W-N
011-US-021
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073325
301CG0W 2"-RWA-011073303-301CG0W-N
011-US-022
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
2"
RWA
011
073326
301CG0W 2"-RWA-011073303-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073326
301CG0W
011-US-024
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073327
301CG0W 2"-RWA-011073326-301CG0W-N
011-US-023
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073328
301CG0W 2"-RWA-011073313-301CG0W-N
011-US-025
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073329
301CG0W 2"-RWA-011073313-301CG0W-N
011-US-026
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073330
301CG0W 2"-RWA-011073354-301CG0W-N
011-US-041
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073331
301CG0W 2"-RWA-011073354-301CG0W-N
011-US-042
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073332
301CG0W 2"-RWA-011073350-301CG0W-N
Hose connection
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073333
301CG0W 2"-RWA-011073308-301CG0W-N
011-US-029
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073334
301CG0W 2"-RWA-011073312-301CG0W-N
011-US-027
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073335
301CG0W 2"-RWA-011073310-301CG0W-N
011-US-028
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073336
301CG0W 2"-RWA-011073305-301CG0W-N
011-US-030
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073337
301CG0W 2"-RWA-011073303-301CG0W-N
011-US-032
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073338
301CG0W 2"-RWA-011073303-301CG0W-N
011-US-031
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
2"
RWA
011
073339
301CG0W 2"-RWA-011073303-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073339
301CG0W
011-US-033
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073340
301CG0W 2"-RWA-011073339-301CG0W-N
011-US-034
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073341
301CG0W 2"-RWA-011073303-301CG0W-N
011-US-035
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
RWA
011
073342
301CG0W 2"-RWA-011073346-301CG0W-N
011-US-040
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073343
301CG0W 2"-RWA-011073303-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073343
301CG0W
011-US-036
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
2"
RWA
011
073344
301CG0W 2"-RWA-011073303-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073344
301CG0W
011-US-037
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
RWA
011
073345
301CG0W 2"-RWA-011073346-301CG0W-N
011-US-038
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
2"
RWA
011
073346
301CG0W 2"-RWA-011073301-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
RWA
011
073346
301CG0W
011-US-039
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073347
301CG0W 2"-RWA-011073350-301CG0W-N
011-US-044
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073348
301CG0W 2"-RWA-011073350-301CG0W-N
011-US-045
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073349
301CG0W 2"-RWA-011073350-301CG0W-N
011-US-046
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
2"
RWA
011
073350
301CG0W 2"-RWA-011073354-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073350
301CG0W
011-US-047
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073351
301CG0W 2"-RWA-011073354-301CG0W-N
011-US-049
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073352
301CG0W 2"-RWA-011073354-301CG0W-N
011-US-048
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
RWA
011
073353
301CG0W 2"-RWA-011073355-301CG0W-N
011-US-051
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
2"
RWA
011
073354
301CG0W 2"-RWA-011073303-301CG0W-N
SA-JER-DS011-TRJR-480307
1"
RWA
011
073354
301CG0W
SA-JER-DS011-TRJR-480307
2"
RWA
011
073355
301CG0W 2"-RWA-011073303-301CG0W-N
SA-JER-DS011-TRJR-480307
1"
RWA
011
073355
301CG0W
SA-JER-DS011-TRJR-480307
1"
RWA
011
073356
SA-JER-DS011-TRJR-480314
2"
RWA
011
SA-JER-DS011-TRJR-480314
1"
RWA
SA-JER-DS011-TRJR-480314
1"
SA-JER-DS011-TRJR-480314
1"
SA-JER-DS011-TRJR-480314
Reducer
Reducer
Reducer
Reducer
Reducer
Reducer
Reducer
Reducer
Reducer
Reducer
Reducer
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
011-US-050
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
011-US-053
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
301CG0W 2"-RWA-011073355-301CG0W-N
011-US-052
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
073357
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-055
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
011
073358
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-054
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
RWA
011
073359
301CG0W 2"-RWA-011073357-301CG0W-N
011-US-059
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
RWA
011
073360
301CG0W 2"-RWA-011073346-301CG0W-N
011-US-057
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
1"
RWA
011
073361
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-058
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
RWA
011
073362
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-059
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073363
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-067
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
Reducer
Reducer
Page 148 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
TO
INSULATION (NOTE 2)
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480308
1"
RWA
011
073364
301CG0W 2"-RWA-011073381-301CG0W-N 1"-RWA-011073364-301CG0W-N
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
RWA
011
073364
301CG0W 1"-RWA-011073364-301CG0W-N
011-US-060
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
RWA
011
073365
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-061
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
RWA
011
073366
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-062
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073367
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-063
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
RWA
011
073368
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-064
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073369
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-065
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073370
301CG0W 2"-RWA-011073301-301CG0W-N
Hose connection
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
1"
RWA
011
073371
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-068
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
RWA
011
073372
301CG0W 2"-RWA-011073382-301CG0W-N
011-US-079
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
1"
RWA
011
073373
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-069
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
1"
RWA
011
073374
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-070
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
RWA
011
073375
301CG0W 2"-RWA-011073381-301CG0W-N
011-US-071
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
RWA
011
073376
301CG0W 2"-RWA-011073381-301CG0W-N
011-US-072
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
RWA
011
073377
301CG0W 2"-RWA-011073382-301CG0W-N
011-US-073
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
RWA
011
073378
301CG0W 2"-RWA-011073382-301CG0W-N
011-US-074
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
RWA
011
073379
301CG0W 2"-RWA-011073381-301CG0W-N
011-US-075
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
RWA
011
073380
301CG0W 2"-RWA-011073381-301CG0W-N
011-US-076
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
2"
RWA
011
073381
301CG0W 2"-RWA-011073301-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
RWA
011
073381
301CG0W
011-US-077
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
2"
RWA
011
073382
301CG0W 2"-RWA-011073301-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
RWA
011
073382
301CG0W
011-US-078
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
RWA
011
073383
301CG0W 2"-RWA-011073382-301CG0W-N
011-US-080
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
RWA
011
073384
301CG0W 2"-RWA-011073382-301CG0W-N
011-US-081
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073385
301CG0W 2"-RWA-011073398-301CG0W-N
011-US-091
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
RWA
011
073386
301CG0W 2"-RWA-011073387-301CG0W-N
011-US-082
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
2"
RWA
011
073387
301CG0W 2"-RWA-011073382-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
RWA
011
073387
301CG0W
011-US-083
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
RWA
011
073388
301CG0W 2"-RWA-011073387-301CG0W-N
011-US-084
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
RWA
011
073389
301CG0W 2"-RWA-011073387-301CG0W-N
011-US-085
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
2"
RWA
011
073390
301CG0W 2"-RWA-011073301-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073390
301CG0W
011-US-086
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073391
301CG0W 2"-RWA-011073398-301CG0W-N
011-US-087
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073392
301CG0W 2"-RWA-011073398-301CG0W-N
011-US-088
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073393
301CG0W 2"-RWA-011073398-301CG0W-N
011-US-089
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073394
301CG0W 2"-RWA-011073398-301CG0W-N
011-US-090
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073395
301CG0W 2"-RWA-011073398-301CG0W-N
011-US-093
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073396
301CG0W 2"-RWA-011073398-301CG0W-N
011-US-092
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073397
301CG0W 2"-RWA-011073398-301CG0W-N
011-US-094
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
2"
RWA
011
073398
301CG0W 2"-RWA-011073390-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073398
301CG0W
011-US-095
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
2"
RWA
011
073399
301CG0W 2"-RWA-011073301-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073399
301CG0W
011-US-096
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073400
301CG0W 2"-RWA-011073410-301CG0W-N
011-US-097
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073401
301CG0W 2"-RWA-011073410-301CG0W-N
011-US-098
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073402
301CG0W 2"-RWA-011073410-301CG0W-N
011-US-100
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073403
301CG0W 2"-RWA-011073410-301CG0W-N
011-US-099
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073404
301CG0W 2"-RWA-011073410-301CG0W-N
011-US-101
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073405
301CG0W 2"-RWA-011073410-301CG0W-N
011-US-105
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073406
301CG0W 2"-RWA-011073410-301CG0W-N
011-US-102
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073407
301CG0W 2"-RWA-011073410-301CG0W-N
011-US-103
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073408
301CG0W 2"-RWA-011073410-301CG0W-N
011-US-104
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
RWA
011
073409
301CG0W 2"-RWA-011073423-301CG0W-N
011-US-107
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
2"
RWA
011
073410
301CG0W 2"-RWA-011073399-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073410
301CG0W
011-US-106
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
RWA
011
073411
301CG0W 2"-RWA-011073423-301CG0W-N
011-US-108
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
RWA
011
073412
301CG0W 2"-RWA-011073423-301CG0W-N
011-US-109
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
RWA
011
073413
301CG0W 2"-RWA-011073423-301CG0W-N
011-US-110
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
2"
RWA
011
073414
301CG0W 2"-RWA-011073301-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073414
301CG0W
011-US-128
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073415
301CG0W 2"-RWA-011073414-301CG0W-N
011-US-121
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
2"
RWA
011
073416
301CG0W 2"-RWA-011073414-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073416
301CG0W
011-US-127
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073417
301CG0W 2"-RWA-011073416-301CG0W-N
011-US-126
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073418
301CG0W 2"-RWA-011073414-301CG0W-N
011-US-126
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073419
301CG0W 2"-RWA-011073420-301CG0W-N
011-US-122
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
2"
RWA
011
073420
301CG0W 2"-RWA-011073301-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073420
301CG0W
011-US-124
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
RWA
011
073421
301CG0W 2"-RWA-011073420-301CG0W-N
011-US-123
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
RWA
011
073422
301CG0W 1"-RWA-011073435-301CG0W-N
011-US-129
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
2"
RWA
011
073423
301CG0W 2"-RWA-011073301-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
RWA
011
073423
301CG0W
011-US-111
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
1"
RWA
011
073424
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-112
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
RWA
011
073425
301CG0W 2"-RWA-011073423-301CG0W-N
011-US-116
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
1"
RWA
011
073426
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-130
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
1"
RWA
011
073427
301CG0W 1"-RWA-011073429-301CG0W-N
011-US-118
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
RWA
011
073428
301CG0W 1"-RWA-011073429-301CG0W-N
011-US-120
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
1"
RWA
011
073429
301CG0W 2"-RWA-011073301-301CG0W-N
SA-JER-DS011-TRJR-480315
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
RWA
011
073429
301CG0W
SA-JER-DS011-TRJR-480310
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
RWA
011
073429
301CG0W
Reducer
011-US-131
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
RWA
011
073430
301CG0W 1"-RWA-011073429-301CG0W-N
011-US-119
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
RWA
011
073431
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-117
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
RWA
011
073433
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-114
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
1"
RWA
011
073434
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-115
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
RWA
011
073435
301CG0W 1"-RWA-011073429-301CG0W-N
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
3/4"
RWA
011
073435
301CG0W
011-US-132
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073436
301CG0W 2"-RWA-011073308-301CG0W-N
011-US-133
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073437
301CG0W 2"-RWA-011073303-301CG0W-N
011-US-134
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
RWA
011
073438
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-0011-US-13556
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
RWA
011
073439
301CG0W 2"-RWA-011073303-301CG0W-N
011-US-136
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
RWA
011
073440
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-137
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
Reducer
Reducer
Reducer
Reducer
Reducer
Reducer
Reducer
Reducer
Reducer
Reducer
Reducer
Reducer
Page 149 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
INSULATION (NOTE 2)
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480314
1"
RWA
011
073441
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-138
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
RWA
011
073442
301CG0W 2"-RWA-011073346-301CG0W-N
011-US-139
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
RWA
011
073443
301CG0W 2"-RWA-011073382-301CG0W-N
011-US-140
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
RWA
011
074432
301CG0W 2"-RWA-011073301-301CG0W-N
011-US-114
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
RWA
011
200301
301CG0W 2"-RWA-011073355-301CG0W-N
SA-JER-DS011-TRJR-480274
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
3/4"
RWA
011
200301
301CG0W
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
3/4"
RWA
011
200302
301CG0W 2"-RWA-011073346-301CG0W-N
SA-JER-DS011-TRJR-480274
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
3/4"
RWA
011
200302
301CG0W
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
3/4"
RWA
011
200303
301CG0W 2"-RWA-011200320-301CG0W-N
SA-JER-DS011-TRJR-480274
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
3/4"
RWA
011
200303
301CG0W
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
3/4"
RWA
011
200304
301CG0W 2"-RWA-011073346-301CG0W-N
SA-JER-DS011-TRJR-480274
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
3/4"
RWA
011
200304
301CG0W
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
3/4"
RWA
011
200305
301CG0W 2"-RWA-011200320-301CG0W-N
SA-JER-DS011-TRJR-480274
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
3/4"
RWA
011
200305
301CG0W
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
3/4"
RWA
011
200306
301CG0W 2"-RWA-011073346-301CG0W-N
SA-JER-DS011-TRJR-480274
3/4"
RWA
011
200306
301CG0W
SA-JER-DS011-TRJR-480209
3/4"
RWA
011
200307
301CG0W 2"-RWA-011073303-301CG0W-N
SA-JER-DS011-TRJR-480274
3/4"
RWA
011
200307
301CG0W
SA-JER-DS011-TRJR-480307
3/4"
RWA
011
200308
301CG0W 2"-RWA-011073326-301CG0W-N
SA-JER-DS011-TRJR-480274
3/4"
RWA
011
200308
301CG0W
SA-JER-DS011-TRJR-480209
3/4"
RWA
011
200309
301CG0W 2"-RWA-011073303-301CG0W-N
SA-JER-DS011-TRJR-480273
3/4"
RWA
011
200309
301CG0W
SA-JER-DS011-TRJR-480307
3/4"
RWA
011
200310
SA-JER-DS011-TRJR-480274
3/4"
RWA
011
200310
SA-JER-DS011-TRJR-480307
SA-JER-DS011-TRJR-480314
SA-JER-DS011-TRJR-480209
SA-JER-DS011-TRJR-480314
SA-JER-DS011-TRJR-480209
SA-JER-DS011-TRJR-480314
SA-JER-DS011-TRJR-480209
SA-JER-DS011-TRJR-480307
SA-JER-DS011-TRJR-480209
3/4"-RWA-011200308-301CG0W301CG0W N 301CG0W SA-JER-DS011-TRJR-480307
SA-JER-DS011-TRJR-480307
3/4"
RWA
011
200311
3/4"-RWA-011200326-301CG0W301CG0W N
SA-JER-DS011-TRJR-480275
3/4"
RWA
011
200311
301CG0W
SA-JER-DS011-TRJR-480308
3/4"
RWA
011
200312
301CG0W 2"-RWA-011073381-301CG0W-N
SA-JER-DS011-TRJR-480275
3/4"
RWA
011
200312
301CG0W
SA-JER-DS011-TRJR-480308
3/4"
RWA
011
200313
301CG0W 2"-RWA-011073382-301CG0W-N
SA-JER-DS011-TRJR-480273
3/4"
RWA
011
200313
301CG0W
SA-JER-DS011-TRJR-480307
SA-JER-DS011-TRJR-480308
SA-JER-DS011-TRJR-480308
SA-JER-DS011-TRJR-480315
3/4"
RWA
011
200314
SA-JER-DS011-TRJR-480275
3/4"
RWA
011
200314
3/4"-RWA-011200316-301CG0W301CG0W N 301CG0W SA-JER-DS011-TRJR-480315
SA-JER-DS011-TRJR-480310
3/4"
RWA
011
200315
301CG0W 2"-RWA-011073301-301CG0W-N
SA-JER-DS011-TRJR-480274
3/4"
RWA
011
200315
301CG0W
SA-JER-DS011-TRJR-480315
3/4"
RWA
011
200316
301CG0W 2"-RWA-011073423-301CG0W-N
SA-JER-DS011-TRJR-480275
3/4"
RWA
011
200316
301CG0W
SA-JER-DS011-TRJR-480209
3/4"
RWA
011
200317
301CG0W 2"-RWA-011073303-301CG0W-N
SA-JER-DS011-TRJR-480274
3/4"
RWA
011
200317
301CG0W
SA-JER-DS011-TRJR-480314
3/4"
RWA
011
200318
301CG0W 2"-RWA-011073346-301CG0W-N
SA-JER-DS011-TRJR-480274
3/4"
RWA
011
200318
301CG0W
SA-JER-DS011-TRJR-480306
3/4"
RWA
011
200319
301CG0W 1"-RWA-011073323-301CG0W-N
SA-JER-DS011-TRJR-480274
3/4"
RWA
011
200319
301CG0W
SA-JER-DS011-TRJR-480209
2"
RWA
011
200320
301CG0W 2"-RWA-011073303-301CG0W-N
SA-JER-DS011-TRJR-480209
3/4"
RWA
011
200320
301CG0W
SA-JER-DS011-TRJR-480274
3/4"
RWA
011
200320
301CG0W
SA-JER-DS011-TRJR-480309
3/4"
RWA
011
200321
301CG0W 2"-RWA-011073410-301CG0W-N
SA-JER-DS011-TRJR-480275
3/4"
RWA
011
200321
301CG0W
SA-JER-DS011-TRJR-480306
3/4"
RWA
011
200322
301CG0W 2"-RWA-011073313-301CG0W-N
SA-JER-DS011-TRJR-480274
3/4"
RWA
011
200322
301CG0W
SA-JER-DS011-TRJR-480315
1"
RWA
011
200323
301CG0W 2"-RWA-011073301-301CG0W-N
SA-JER-DS011-TRJR-480274
1"
RWA
011
200323
301CG0W
SA-JER-DS011-TRJR-480308
3/4"
RWA
011
200324
301CG0W 2"-RWA-011073381-301CG0W-N
SA-JER-DS011-TRJR-480275
3/4"
RWA
011
200324
301CG0W
SA-JER-DS011-TRJR-480209
3/4"
RWA
011
200325
301CG0W 2"-RWA-011073303-301CG0W-N
SA-JER-DS011-TRJR-480274
3/4"
RWA
011
200325
301CG0W
SA-JER-DS011-TRJR-480307
3/4"
RWA
011
200326
301CG0W 2"-RWA-011073354-301CG0W-N
SA-JER-DS011-TRJR-480274
3/4"
RWA
011
200326
301CG0W
SA-JER-DS011-TRJR-480308
1"
SAI
011
074074
SA-JER-DS011-TRJR-480308
3/4"
SAI
011
SA-JER-DS011-TRJR-480211
3"
SAI
SA-JER-DS011-TRJR-480212
3"
SAI
SA-JER-DS011-TRJR-480212
3"
SAI
SA-JER-DS011-TRJR-480213
3"
SA-JER-DS011-TRJR-480306 SA-JER-DS011-TRJR-480306
SA-JER-DS011-TRJR-480310
SA-JER-DS011-TRJR-480315
SA-JER-DS011-TRJR-480209
SA-JER-DS011-TRJR-480274
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480273
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480275
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480275
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480273
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480275
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480275
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
Reducer
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
Reducer
SA-JER-DS011-TRJR-480274
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480275
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480275
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
SA-JER-DS011-TRJR-480306
SA-JER-DS011-TRJR-480309
SA-JER-DS011-TRJR-480306
SA-JER-DS011-TRJR-480315
SA-JER-DS011-TRJR-480308
SA-JER-DS011-TRJR-480274
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480274
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
SAMPLE COOLER
-
-
N
-
SERVICE WATER
Liquid
994
4.50
35.00
-
-
8.00
80.00
-
H
12.00
D
By Code
NO
N
N
N
N
N
N
-
-
301CG2P
2"-SAI-011074380-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
074074
301CG2P
Reducer
011-US-071
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
011
074301
301CG2P
IP-1323
SA-JER-DS011-TRJR-480212
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
011
074301
301CG2P
SA-JER-DS011-TRJR-480211
HEADER
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
011
074302
301CG2P
3"-SAI-011074301-301CG2P-N
SA-JER-DS011-TRJR-480213
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SAI
011
074302
301CG2P
SA-JER-DS011-TRJR-480212
HEADER
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
1"
SAI
011
074303
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
3/4"
SAI
011
074303
301CG2P
Reducer
011-US-001
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480209
SA-JER-DS011-TRJR-480306
1"
SAI
011
074304
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074304
301CG2P
Reducer
011-US-002
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
2"
SAI
011
074305
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074305
301CG2P
Reducer
011-US-003
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074306
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074306
301CG2P
Reducer
011-US-004
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074307
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074307
301CG2P
Reducer
011-US-006
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
2"
SAI
011
074308
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074308
301CG2P
Reducer
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074308
301CG2P
Reducer
011-US-005
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074309
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074309
301CG2P
Reducer
011-US-008
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
2"
SAI
011
074310
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074310
301CG2P
Reducer
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074310
301CG2P
Reducer
011-US-007
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074311
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074311
301CG2P
Reducer
011-US-010
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
2"
SAI
011
074312
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074312
301CG2P
Reducer
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074312
301CG2P
Reducer
011-US-009
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
2"
SAI
011
074313
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074313
301CG2P
Reducer
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074313
301CG2P
Reducer
011-US-011
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074314
301CG2P
2"-SAI-011074344-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
ASME N/A
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
Page 150 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9) SAI
UNIT
NUMBER
LINE CLASS
011
074314
INSULATION (NOTE 2)
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
011-US-012
-
-
N
-
FLUID
PHASE
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
Gas
-
7.50
45.00
-
-
PRESS. (BARG)
80.00
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
-
PNEU
13.20
ASME N/A
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
301CG2P
Reducer
1"
SAI
011
074315
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074315
301CG2P
Reducer
011-US-014
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
UTILITY AIR
12.00
TEMP. (ºC)
STRESS TEMP
SA-JER-DS011-TRJR-380001
SA-JER-DS011-TRJR-480307
SA-JER-DS011-TRJR-480306
3/4"
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
DOC. No.
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074316
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074316
301CG2P
Reducer
011-US-013
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074317
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074317
301CG2P
Reducer
011-US-016
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074318
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074318
301CG2P
Reducer
011-US-015
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074319
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074319
301CG2P
Reducer
011-US-017
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
2"
SAI
011
074320
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074320
301CG2P
Reducer
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074320
301CG2P
Reducer
011-US-018
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074321
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074321
301CG2P
Reducer
011-US-020
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074322
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074322
301CG2P
Reducer
011-US-019
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
SAI
011
074323
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
3/4"
SAI
011
074323
301CG2P
Reducer
011-US-059
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074324
301CG2P
2"-SAI-011074320-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074324
301CG2P
Reducer
011-US-021
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074325
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074325
301CG2P
Reducer
011-US-022
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
2"
SAI
011
074326
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074326
301CG2P
Reducer
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074326
301CG2P
Reducer
011-US-024
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074327
301CG2P
2"-SAI-011074326-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074327
301CG2P
Reducer
011-US-023
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074328
301CG2P
2"-SAI-011074313-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074328
301CG2P
Reducer
011-US-025
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074329
301CG2P
2"-SAI-011074313-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074329
301CG2P
Reducer
011-US-026
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074330
301CG2P
2"-SAI-011074354-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074330
301CG2P
Reducer
011-US-041
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074331
301CG2P
2"-SAI-011074354-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074331
301CG2P
Reducer
011-US-042
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074332
301CG2P
2"-SAI-011074350-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074332
301CG2P
Reducer
011-US-043
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074333
301CG2P
2"-SAI-011074308-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074333
301CG2P
Reducer
011-US-029
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074334
301CG2P
2"-SAI-011074312-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074334
301CG2P
Reducer
011-US-027
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074335
301CG2P
2"-SAI-011074310-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074335
301CG2P
Reducer
011-US-028
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074336
301CG2P
2"-SAI-011074305-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074336
301CG2P
Reducer
011-US-030
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074337
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074337
301CG2P
Reducer
011-US-032
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074338
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074338
301CG2P
Reducer
011-US-031
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
2"
SAI
011
074339
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074339
301CG2P
Reducer
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074339
301CG2P
Reducer
011-US-033
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074340
301CG2P
2"-SAI-011074339-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074340
301CG2P
Reducer
011-US-034
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074341
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074341
301CG2P
Reducer
011-US-035
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
SAI
011
074342
301CG2P
2"-SAI-011074346-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
3/4"
SAI
011
074342
301CG2P
Reducer
011-US-040
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074343
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074343
301CG2P
Reducer
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074343
301CG2P
Reducer
011-US-036
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
SERVICE AIR
SA-JER-DS011-TRJR-480306
1"
SAI
011
074344
301CG2P
Reducer
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074344
301CG2P
Reducer
011-US-037
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
SAI
011
074345
301CG2P
2"-SAI-011074346-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
3/4"
SAI
011
074345
301CG2P
Reducer
011-US-038
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
2"
SAI
011
074346
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
SAI
011
074346
301CG2P
Reducer
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
3/4"
SAI
011
074346
301CG2P
Reducer
011-US-039
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
2"
SAI
011
074344
-
-
N
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074347
301CG2P
2"-SAI-011074350-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074347
301CG2P
Reducer
011-US-044
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074348
301CG2P
2"-SAI-011074350-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074348
301CG2P
Reducer
011-US-045
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074349
301CG2P
2"-SAI-011074350-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074349
301CG2P
Reducer
011-US-046
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
2"
SAI
011
074350
301CG2P
2"-SAI-011074354-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074350
301CG2P
Reducer
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074350
301CG2P
Reducer
011-US-047
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074351
301CG2P
2"-SAI-011074354-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074351
301CG2P
Reducer
011-US-049
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074352
301CG2P
2"-SAI-011074354-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074352
301CG2P
Reducer
011-US-048
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074353
301CG2P
2"-SAI-011074355-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074353
301CG2P
Reducer
011-US-051
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
301CG2P
3"-SAI-011074301-301CG2P-N
SA-JER-DS011-TRJR-480307
2"
SAI
011
074354
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074354
301CG2P
Reducer
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074354
301CG2P
Reducer
011-US-050
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
2"
SAI
011
074355
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
1"
SAI
011
074355
301CG2P
Reducer
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
Page 151 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9) SAI
UNIT
NUMBER
LINE CLASS
011
074355
INSULATION (NOTE 2)
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
011-US-053
-
-
N
-
FLUID
PHASE
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
Gas
-
7.50
45.00
-
-
PRESS. (BARG)
80.00
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
-
PNEU
13.20
NFS
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
301CG2P
Reducer
1"
SAI
011
074356
301CG2P
2"-SAI-011074355-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480307
3/4"
SAI
011
074356
301CG2P
Reducer
011-US-052
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SERVICE AIR
12.00
TEMP. (ºC)
STRESS TEMP
SA-JER-DS011-TRJR-380001
SA-JER-DS011-TRJR-480307
SA-JER-DS011-TRJR-480307
3/4"
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
DOC. No.
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
2"
SAI
011
074357
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
3/4"
SAI
011
074357
301CG2P
Reducer
011-US-055
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
SAI
011
074358
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
3/4"
SAI
011
074358
301CG2P
Reducer
011-US-054
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
SAI
011
074359
301CG2P
2"-SAI-011074357-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
3/4"
SAI
011
074359
301CG2P
Reducer
011-US-056
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
SAI
011
074360
301CG2P
2"-SAI-011074346-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
3/4"
SAI
011
074360
301CG2P
Reducer
011-US-057
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
SAI
011
074361
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
3/4"
SAI
011
074361
301CG2P
Reducer
011-US-058
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074362
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074362
301CG2P
Reducer
011-US-067
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
SAI
011
074363
301CG2P
2"-SAI-011074380-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
3/4"
SAI
011
074363
301CG2P
Reducer
011-US-060
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
SAI
011
074364
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
3/4"
SAI
011
074364
301CG2P
Reducer
011-US-061
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
SAI
011
074365
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
3/4"
SAI
011
074365
301CG2P
Reducer
011-US-062
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074366
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074366
301CG2P
Reducer
011-US-063
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
SAI
011
074367
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
3/4"
SAI
011
074367
301CG2P
Reducer
011-US-064
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074368
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074368
301CG2P
Reducer
011-US-065
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074369
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074369
301CG2P
Reducer
Hose connection
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
1"
SAI
011
074370
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
3/4"
SAI
011
074370
301CG2P
Reducer
011-US-068
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
SAI
011
074371
301CG2P
2"-SAI-011074381-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
3/4"
SAI
011
074371
301CG2P
Reducer
011-US-079
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
1"
SAI
011
074372
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
3/4"
SAI
011
074372
301CG2P
Reducer
011-US-069
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
1"
SAI
011
074373
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
3/4"
SAI
011
074373
301CG2P
Reducer
011-US-070
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
SAI
011
074375
301CG2P
2"-SAI-011074380-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
3/4"
SAI
011
074375
301CG2P
Reducer
011-US-072
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
SAI
011
074376
301CG2P
2"-SAI-011074381-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
3/4"
SAI
011
074376
301CG2P
Reducer
011-US-073
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
SAI
011
074377
301CG2P
2"-SAI-011074381-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
3/4"
SAI
011
074377
301CG2P
Reducer
011-US-074
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
SAI
011
074378
301CG2P
2"-SAI-011074380-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
3/4"
SAI
011
074378
301CG2P
Reducer
011-US-075
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
SAI
011
074379
301CG2P
2"-SAI-011074380-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
3/4"
SAI
011
074379
301CG2P
Reducer
011-US-076
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
2"
SAI
011
074380
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
SAI
011
074380
301CG2P
Reducer
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
3/4"
SAI
011
074380
301CG2P
Reducer
011-US-077
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
301CG2P
3"-SAI-011074301-301CG2P-N
SA-JER-DS011-TRJR-480308
2"
SAI
011
074381
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
SAI
011
074381
301CG2P
Reducer
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
3/4"
SAI
011
074381
301CG2P
Reducer
011-US-078
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
SAI
011
074382
301CG2P
2"-SAI-011074381-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
3/4"
SAI
011
074382
301CG2P
Reducer
011-US-080
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
SAI
011
074383
301CG2P
2"-SAI-011074381-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
3/4"
SAI
011
074383
301CG2P
Reducer
011-US-081
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074384
301CG2P
2"-SAI-011074397-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074384
301CG2P
Reducer
011-US-091
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
SAI
011
074385
301CG2P
2"-SAI-011074386-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
3/4"
SAI
011
074385
301CG2P
Reducer
011-US-082
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
2"
SAI
011
074386
301CG2P
2"-SAI-011074381-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
SAI
011
074386
301CG2P
Reducer
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
3/4"
SAI
011
074386
301CG2P
Reducer
011-US-083
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
SAI
011
074387
301CG2P
2"-SAI-011074386-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
3/4"
SAI
011
074387
301CG2P
Reducer
011-US-084
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
SAI
011
074388
301CG2P
2"-SAI-011074386-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
3/4"
SAI
011
074388
301CG2P
Reducer
011-US-085
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
2"
SAI
011
074389
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074389
301CG2P
Reducer
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074389
301CG2P
Reducer
011-US-086
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074390
301CG2P
2"-SAI-011074397-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074390
301CG2P
Reducer
011-US-087
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074391
301CG2P
2"-SAI-011074397-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074391
301CG2P
Reducer
011-US-088
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074392
301CG2P
2"-SAI-011074397-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074392
301CG2P
Reducer
011-US-089
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074393
301CG2P
2"-SAI-011074397-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074393
301CG2P
Reducer
011-US-090
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074394
301CG2P
2"-SAI-011074397-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074394
301CG2P
Reducer
011-US-093
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074395
301CG2P
2"-SAI-011074397-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074395
301CG2P
Reducer
011-US-092
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074396
301CG2P
2"-SAI-011074397-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074396
301CG2P
Reducer
011-US-094
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
301CG2P
2"-SAI-011074389-301CG2P-N
SA-JER-DS011-TRJR-480309
2"
SAI
011
074397
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074397
301CG2P
Reducer
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074397
301CG2P
Reducer
011-US-095
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
2"
SAI
011
074398
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074398
301CG2P
Reducer
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074398
301CG2P
Reducer
011-US-096
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
Page 152 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
INSULATION (NOTE 2)
TYPE
FLUID
THICKNESS (mm)
PHASE
(NOTE 3)
DOC. No.
DENSITY (kg/m3)
(NOTE 4)
OPERATING CONDITIONS PRESS. (BARG)
TEMP. (ºC)
DESIGN CONDITIONS
ALTERNATE CONDITIONS PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
(ºC)
TEST CONDITIONS
MEDIUM (NOTE 5)
PRESS. (BARG)
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6)
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480309
1"
SAI
011
074399
301CG2P
2"-SAI-011074409-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074399
301CG2P
Reducer
011-US-097
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074400
301CG2P
2"-SAI-011074409-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074400
301CG2P
Reducer
011-US-098
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074401
301CG2P
2"-SAI-011074409-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074401
301CG2P
Reducer
011-US-100
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074402
301CG2P
2"-SAI-011074409-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074402
301CG2P
Reducer
011-US-099
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074403
301CG2P
2"-SAI-011074409-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074403
301CG2P
Reducer
011-US-101
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074404
301CG2P
2"-SAI-011074409-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074404
301CG2P
Reducer
011-US-105
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074405
301CG2P
2"-SAI-011074409-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074405
301CG2P
Reducer
011-US-102
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074406
301CG2P
2"-SAI-011074409-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074406
301CG2P
Reducer
011-US-103
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074407
301CG2P
2"-SAI-011074409-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074407
301CG2P
Reducer
011-US-104
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
SAI
011
074408
301CG2P
2"-SAI-011074421-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
3/4"
SAI
011
074408
301CG2P
Reducer
011-US-107
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
2"
SAI
011
074409
301CG2P
2"-SAI-011074398-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074409
301CG2P
Reducer
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074409
301CG2P
Reducer
011-US-106
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
SAI
011
074410
301CG2P
2"-SAI-011074421-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
3/4"
SAI
011
074410
301CG2P
Reducer
011-US-108
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
SAI
011
074411
301CG2P
2"-SAI-011074421-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
3/4"
SAI
011
074411
301CG2P
Reducer
011-US-109
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
SAI
011
074412
301CG2P
2"-SAI-011074421-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
3/4"
SAI
011
074412
301CG2P
Reducer
011-US-110
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
301CG2P
3"-SAI-011074301-301CG2P-N
SA-JER-DS011-TRJR-480309
2"
SAI
011
074413
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074413
301CG2P
Reducer
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074413
301CG2P
Reducer
011-US-128
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074414
301CG2P
2"-SAI-011074413-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074414
301CG2P
Reducer
011-US-121
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
SAI
011
074415
301CG2P
1"-SAI-011074434-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
3/4"
SAI
011
074415
301CG2P
Reducer
011-US-129
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074416
301CG2P
2"-SAI-011074433-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074416
301CG2P
Reducer
011-US-126
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074417
301CG2P
2"-SAI-011074413-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074417
301CG2P
Reducer
011-US-126
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074418
301CG2P
2"-SAI-011074419-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074418
301CG2P
Reducer
011-US-122
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
301CG2P
3"-SAI-011074301-301CG2P-N
SA-JER-DS011-TRJR-480309
2"
SAI
011
074419
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074419
301CG2P
Reducer
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074419
301CG2P
Reducer
011-US-124
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074420
301CG2P
2"-SAI-011074419-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074420
301CG2P
Reducer
011-US-123
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
2"
SAI
011
074421
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
SAI
011
074421
301CG2P
Reducer
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
3/4"
SAI
011
074421
301CG2P
Reducer
011-US-111
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
1"
SAI
011
074422
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
3/4"
SAI
011
074422
301CG2P
Reducer
011-US-112
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
SAI
011
074423
301CG2P
2"-SAI-011074421-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
3/4"
SAI
011
074423
301CG2P
Reducer
011-US-116
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
1"
SAI
011
074424
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
3/4"
SAI
011
074424
301CG2P
Reducer
011-US-130
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
1"
SAI
011
074425
301CG2P
1"-SAI-011074427-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
3/4"
SAI
011
074425
301CG2P
Reducer
011-US-118
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
SAI
011
074426
301CG2P
1"-SAI-011074427-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
3/4"
SAI
011
074426
301CG2P
Reducer
011-US-120
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
1"
SAI
011
074427
301CG2P
3"-SAI-011074301-301CG2P-N
SA-JER-DS011-TRJR-480315
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
SAI
011
074427
301CG2P
SA-JER-DS011-TRJR-480310
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
SAI
011
074427
301CG2P
Reducer
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
3/4"
SAI
011
074427
301CG2P
Reducer
011-US-131
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
SAI
011
074428
301CG2P
1"-SAI-011074427-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
3/4"
SAI
011
074428
301CG2P
Reducer
011-US-119
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
SAI
011
074429
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
3/4"
SAI
011
074429
301CG2P
Reducer
011-US-117
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
SAI
011
074430
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
3/4"
SAI
011
074430
301CG2P
Reducer
011-US-114
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
SAI
011
074431
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
3/4"
SAI
011
074431
301CG2P
Reducer
011-US-113
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
1"
SAI
011
074432
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480310
3/4"
SAI
011
074432
301CG2P
Reducer
011-US-115
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
2"
SAI
011
074433
301CG2P
2"-SAI-011074413-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
1"
SAI
011
074433
301CG2P
Reducer
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480309
3/4"
SAI
011
074433
301CG2P
Reducer
011-US-127
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1"
SAI
011
074434
301CG2P
1"-SAI-011074427-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480315
3/4"
SAI
011
074434
301CG2P
Reducer
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480315
1/4"
SAI
011
074434
301CG2P
Reducer
011-US-132
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074435
301CG2P
2"-SAI-011074308-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074435
301CG2P
Reducer
011-US-133
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074436
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
3/4"
SAI
011
074436
301CG2P
Reducer
011-US-134
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
SAI
011
074437
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
3/4"
SAI
011
074437
301CG2P
Reducer
011-US-135
-
-
N
-
SERVICE AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
301CG2P
3"-SAI-011074301-301CG2P-N
SA-JER-DS011-TRJR-480314
1"
SAI
011
074439
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
3/4"
SAI
011
074439
301CG2P
Reducer
011-US-137
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480306
1"
SAI
011
074438
011-US-136
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
1"
SAI
011
074440
301CG2P
3"-SAI-011074301-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
3/4"
SAI
011
074440
301CG2P
Reducer
011-US-138
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
Page 153 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
UNIT
NUMBER
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
INSULATION (NOTE 2)
TYPE
FLUID
THICKNESS (mm)
PHASE
(NOTE 3)
DOC. No.
DENSITY (kg/m3)
(NOTE 4)
OPERATING CONDITIONS PRESS. (BARG)
TEMP. (ºC)
DESIGN CONDITIONS
ALTERNATE CONDITIONS PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
(ºC)
TEST CONDITIONS
MEDIUM (NOTE 5)
PRESS. (BARG)
FLUID CATEGORY (ASME B.31.3)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
(NOTE 6)
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480314
1"
SAI
011
074441
301CG2P
2"-SAI-011074346-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480314
3/4"
SAI
011
074441
301CG2P
Reducer
011-US-139
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
1"
SAI
011
074442
301CG2P
2"-SAI-011074381-301CG2P-N
Reducer
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480308
3/4"
SAI
011
074442
301CG2P
Reducer
011-US-140
-
-
N
-
UTILITY AIR
Gas
-
7.50
45.00
-
-
12.00
80.00
-
PNEU
13.20
NFS
By Code
NO
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480241
4"
SAW
011
081001
101CS2W
011-BA-0001
Hose connection
-
-
N
-
SANITARY WATER
Liquid
1000
0.00
27.00
-
-
0.00
55.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480241
4"
SAW
011
081002
101CS2W
011-BA-0002
Hose connection
-
-
N
-
SANITARY WATER
Liquid
1000
0.00
27.00
-
-
0.00
55.00
-
H
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480241
4"
SAW
011
081003
101CS2W
011-BA-0001
ATM
-
-
N
-
SANITARY WATER
Liquid
1000
0.00
27.00
-
-
0.00
55.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480241
4"
SAW
011
081004
101CS2W
011-BA-0002
ATM
-
-
N
-
SANITARY WATER
Liquid
1000
0.00
27.00
-
-
0.00
55.00
-
Visual Test
0.00
ASME N/A
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480001
3/4"
SLP
011
001001
103CS1P
6"-SLP-011098002-103CS1P-N
Reducer
-
-
N
-
SLOP OIL
Liquid
880
3.20
43.00
-
-
20.00
88.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480001
2"
SLP
011
001001
103CS1P
Reducer
2"-CLD-011001307-101CH2S-N
-
-
N
-
SLOP OIL
Liquid
880
3.20
43.00
-
-
20.00
88.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480001
3/4"
SLP
011
001001
103CS1P
6"-SLP-011098002-103CS1P-N
3/4"-SLP-011001001-103CS1P-N
-
-
N
-
SLOP OIL
Liquid
880
3.20
43.00
-
-
20.00
88.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480001
8"
SLP
011
001002
103CS1P
8"-SLP-011098002-103CS1P-N
011-SP-0019
-
-
N
-
SLOP OIL
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR BLOCKED OUTLET: 43º C. NOTE 6
SA-JER-DS011-TRJR-480001
8"
SLP
011
001002
103CS1P
011-SP-0019
Reducer
-
-
N
-
SLOP OIL
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR BLOCKED OUTLET: 43º C.
SA-JER-DS011-TRJR-480001
3"
SLP
011
001002
103CS1P
Reducer
011-PZV-0078-A
-
-
N
-
SLOP OIL
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR BLOCKED OUTLET: 43º C.
SA-JER-DS011-TRJR-480001
8"
SLP
011
001002
103CS1P
8"-SLP-011001002-103CS1P-N
011-SP-0019
-
-
N
-
SLOP OIL
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR BLOCKED OUTLET: 43º C. NOTE 6
SA-JER-DS011-TRJR-480001
8"
SLP
011
001002
103CS1P
011-SP-0019
Reducer
-
-
N
-
SLOP OIL
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR BLOCKED OUTLET: 43º C.
SA-JER-DS011-TRJR-480001
3"
SLP
011
001002
103CS1P
Reducer
011-PZV-0078-B
-
-
N
-
SLOP OIL
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR BLOCKED OUTLET: 43º C.
SA-JER-DS011-TRJR-480001
3/4"
SLP
011
001002
103CS1P
8"-SLP-011001002-103CS1P-N
3/4"-LFL-011001301-101CH2F-N
-
-
N
-
SLOP OIL
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR BLOCKED OUTLET: 43º C.
SA-JER-DS011-TRJR-480001
3/4"
SLP
011
001002
103CS1P
8"-SLP-011001002-103CS1P-N
3/4"-LFL-011001301-101CH2F-N
-
-
N
-
SLOP OIL
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR BLOCKED OUTLET: 43º C.
SA-JER-DS011-TRJR-480001
3/4"
SLP
011
001003
103CS1P
6"-SLP-011098002-103CS1P-N
011-SC-0051
-
-
N
-
SLOP OIL
Liquid
880
3.20
43.00
-
-
20.00
88.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480275
4"
SLP
011
001003
103CS1P
Reducer
Reducer
-
-
N
-
SLOP OIL
Liquid
880
3.20
43.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480275
3/4"
SLP
011
001003
103CS1P
Reducer
3/4"-SLP-011001004-103CS1P-N
-
-
N
-
SLOP OIL
Liquid
880
3.20
43.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480275
3/4"
SLP
011
001003
103CS1P
3/4"-SLP-011001003-103CS1P-N
Reducer
-
-
N
-
SLOP OIL
Liquid
880
3.20
43.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480275
1/2"
SLP
011
001003
103CS1P
Reducer
Reducer
-
-
N
-
SLOP OIL
Liquid
880
3.20
43.00
-
-
20.00
80.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480275
1/4"
SLP
011
001003
103CS1P
Reducer
SAMPLE CYLINDER
-
-
N
-
SLOP OIL
Liquid
880
3.20
43.00
-
-
20.00
80.00
-
-
-
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480001
3/4"
SLP
011
001004
103CS1P
011-SC-0051
6"-SLP-011098002-103CS1P-N
-
-
N
-
SLOP OIL
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480275
3/4"
SLP
011
001004
103CS1P
3/4"-SLP-011001004-103CS1P-N
Reducer
-
-
N
-
SLOP OIL
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480275
1/2"
SLP
011
001004
103CS1P
Reducer
Reducer
-
-
N
-
SLOP OIL
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480275
3/4"
SLP
011
001004
103CS1P
Reducer
Reducer
-
-
N
-
SLOP OIL
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480275
2"
SLP
011
001004
103CS1P
Reducer
2"-CLD-011200329-101CH2S-N
-
-
N
-
SLOP OIL
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480275
1/4"
SLP
011
001004
103CS1P
SAMPLE CYLINDER
Reducer
-
-
N
-
SLOP OIL
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
-
-
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480275
1/2"
SLP
011
001004
103CS1P
Reducer
1/2"-SLP-011001004-103CS1P-N
-
-
N
-
SLOP OIL
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTES 6,7
SA-JER-DS011-TRJR-480002
2"
SLP
011
002001
103CS1P
12"-SLP-011098019-103CS1P-H
Insul Brk
-
-
H
25
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
2"
SLP
011
002001
103CS1P
Insul Brk
2"-CLD-011002309-101CH2S-P
-
-
P
25
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
2"
SLP
011
076001
103CH2S
011-G-0026-A
Reducer
-
-
P
25
SLOP OIL
Liquid
1000
9.40
200.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
6"
SLP
011
076001
103CH2S
Reducer
SA-JER-DS011-TRJR-480136
-
-
P
40
SLOP OIL
Liquid
1000
9.40
200.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
1/2"
SLP
011
076001
103CH2S
011-FE-0104
011-FT-0104
-
-
P
25
SLOP OIL
Liquid
1000
9.40
200.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
1/2"
SLP
011
076001
103CH2S
011-FE-0104
011-FT-0104
-
-
P
25
SLOP OIL
Liquid
1000
9.40
200.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
3/4"
SLP
011
076001
103CH2S
6"-SLP-011076001-103CH2S-P
011-PI-0290
-
-
P
25
SLOP OIL
Liquid
1000
9.40
200.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
6"
SLP
011
076001
103CH2S
SA-JER-DS011-TRJR-480219
6"-SLP-011099001-103CS1P-S
-
-
P
40
SLOP OIL
Liquid
650
9.40
200.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
3/4"
SLP
011
076001
103CH2S
6"-SLP-011076001-103CH2S-P
3/4"-SLP-011076007-103CH2S-P
-
-
P
25
SLOP OIL
Liquid
1000
9.40
200.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
10"
SLP
011
076002
101CH2S
011-D-0018
Reducer
-
-
P
25
SLOP OIL
Liquid
1000
0.20
40.00
-
-
3.50
400.00
-
H
8.13
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
8"
SLP
011
076002
101CH2S
Reducer
8"-SLP-011076003-103CH2S-P
-
-
P
25
SLOP OIL
Liquid
1000
0.20
40.00
-
-
3.50
400.00
-
H
8.13
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
8"
SLP
011
076003
103CH2S
8"-SLP-011076002-101CH2S-P
Reducer
-
-
P
25
SLOP OIL
Liquid
1000
0.20
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
2"
SLP
011
076003
103CH2S
8"-SLP-011076003-103CH2S-P
UC
-
-
P
25
SLOP OIL
Liquid
1000
0.20
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
3/4"
SLP
011
076003
103CH2S
8"-SLP-011076003-103CH2S-P
011-PI-0307
-
-
P
25
SLOP OIL
Liquid
1000
0.20
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
4"
SLP
011
076003
103CH2S
Reducer
011-G-0026-B
-
-
P
25
SLOP OIL
Liquid
1000
0.20
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
2"
SLP
011
076003
103CH2S
2"-FLO-011076302-101CS1P-N
8"-SLP-011076003-103CH2S-P
-
-
P
25
SLOP OIL
Liquid
1000
0.20
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
3/4"
SLP
011
076003
103CH2S
2"-SLP-011076003-103CH2S-P
Blind flange
-
-
P
25
SLOP OIL
Liquid
1000
0.20
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
8"
SLP
011
076004
103CH2S
8"-SLP-011076005-101CH2S-P
Reducer
-
-
P
25
SLOP OIL
Liquid
1000
0.20
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
3/4"
SLP
011
076004
103CH2S
8"-SLP-011076004-103CH2S-P
011-PI-0304
-
-
P
25
SLOP OIL
Liquid
1000
0.20
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
2"
SLP
011
076004
103CH2S
8"-SLP-011076004-103CH2S-P
UC
-
-
P
25
SLOP OIL
Liquid
1000
0.20
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
4"
SLP
011
076004
103CH2S
Reducer
011-G-0026-A
-
-
P
25
SLOP OIL
Liquid
1000
0.20
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
2"
SLP
011
076004
103CH2S
2"-FLO-011076301-101CS1P-N
8"-SLP-011076004-103CH2S-P
-
-
P
25
SLOP OIL
Liquid
1000
0.20
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
3/4"
SLP
011
076004
103CH2S
2"-SLP-011076004-103CH2S-P
Blind flange
-
-
P
25
SLOP OIL
Liquid
1000
0.20
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
10"
SLP
011
076005
101CH2S
10"-SLP-011076002-101CH2S-P
Reducer
-
-
P
25
SLOP OIL
Liquid
1000
0.20
40.00
-
-
3.50
400.00
-
H
8.13
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
8"
SLP
011
076005
101CH2S
Reducer
8"-SLP-011076004-103CH2S-P
-
-
P
25
SLOP OIL
Liquid
1000
0.20
40.00
-
-
3.50
400.00
-
H
8.13
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
2"
SLP
011
076006
103CH2S
011-G-0026-B
Reducer
-
-
P
25
SLOP OIL
Liquid
1000
9.40
200.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
6"
SLP
011
076006
103CH2S
Reducer
6"-SLP-011076001-103CH2S-P
-
-
P
40
SLOP OIL
Liquid
1000
9.40
200.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
3/4"
SLP
011
076006
103CH2S
6"-SLP-011076006-103CH2S-P
011-PI-0291
-
-
P
25
SLOP OIL
Liquid
1000
9.40
200.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
3/4"
SLP
011
076006
103CH2S
6"-SLP-011076006-103CH2S-P
3/4"-SLP-011076008-103CH2S-P
-
-
P
25
SLOP OIL
Liquid
1000
9.40
200.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
2"
SLP
011
076007
103CH2S
6"-SLP-011076001-103CH2S-P
2"-CLD-011076302-101CS2P-P
-
-
P
25
SLOP OIL
Liquid
1000
9.40
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
3/4"
SLP
011
076007
103CH2S
2"-SLP-011076007-103CH2S-P
3/4"-OLW-011076303-101CS1PN
-
-
P
25
SLOP OIL
Liquid
1000
9.40
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
2"
SLP
011
076007
103CH2S
8"-SLP-011076004-103CH2S-P
2"-SLP-011076007-103CH2S-P
-
-
P
25
SLOP OIL
Liquid
1000
9.40
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
1"
SLP
011
076007
103CH2S
Reducer
2"-SLP-011076007-103CH2S-P
-
-
P
25
SLOP OIL
Liquid
1000
9.40
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
3/4"
SLP
011
076007
103CH2S
011-G-0026-A
Reducer
-
-
P
25
SLOP OIL
Liquid
1000
9.40
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
3/4"
SLP
011
076007
103CH2S
011-G-0026-A
2"-SLP-011076007-103CH2S-P
-
-
P
25
SLOP OIL
Liquid
1000
9.40
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
3/4"
SLP
011
076007
103CH2S
3/4"-SLP-011076001-103CH2S-P
2"-SLP-011076007-103CH2S-P
-
-
P
25
SLOP OIL
Liquid
1000
9.40
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
2"
SLP
011
076008
103CH2S
6"-SLP-011076006-103CH2S-P
2"-CLD-011076303-101CS2P-P
-
-
P
25
SLOP OIL
Liquid
1000
9.40
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
-
-
P
25
SLOP OIL
Liquid
1000
9.40
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
3/4"
SLP
011
076008
103CH2S
2"-SLP-011076008-103CH2S-P
3/4"-OLW-011076304-101CS1PN
SA-JER-DS011-TRJR-480219
2"
SLP
011
076008
103CH2S
8"-SLP-011076003-103CH2S-P
2"-SLP-011076008-103CH2S-P
-
-
P
25
SLOP OIL
Liquid
1000
9.40
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
3/4"
SLP
011
076008
103CH2S
011-G-0026-B
Reducer
-
-
P
25
SLOP OIL
Liquid
1000
9.40
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
1"
SLP
011
076008
103CH2S
Reducer
2"-SLP-011076008-103CH2S-P
-
-
P
25
SLOP OIL
Liquid
1000
9.40
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
3/4"
SLP
011
076008
103CH2S
011-G-0026-B
2"-SLP-011076008-103CH2S-P
-
-
P
25
SLOP OIL
Liquid
1000
9.40
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
3/4"
SLP
011
076008
103CH2S
3/4"-SLP-011076006-103CH2S-P
2"-SLP-011076008-103CH2S-P
-
-
P
25
SLOP OIL
Liquid
1000
9.40
40.00
-
-
23.00
400.00
-
H
53.40
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
3/4"
SLP
011
076009
101CH2S
011-LG-0087
Reducer
-
-
P
25
SLOP OIL
Liquid
1000
0.20
40.00
-
170.00
3.50
400.00
-
H
8.13
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
3/4"
SLP
011
076009
101CH2S
3/4"-SLP-011076009-101CH2S-P
3/4"-OLW-011076302-101CS1PN
-
-
P
25
SLOP OIL
Liquid
1000
0.20
40.00
-
170.00
3.50
400.00
-
H
8.13
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
2"
SLP
011
076009
101CH2S
Reducer
2"-CLD-011076301-101CH2S-P
-
-
P
25
SLOP OIL
Liquid
1000
0.20
40.00
-
170.00
3.50
400.00
-
H
8.13
NFS
YES
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
4"
SLP
011
076010
101CH2S
011-D-0018
4"-OLW-011076301-101CS1P-N
-
-
P
40
SLOP OIL
Liquid
200
0.20
200.00
-
-
3.50
400.00
-
H
8.13
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
3"
SLP
011
076012
103CH2S
3"-MPS-011076301-103CS1P-H
011-D-0018
-
-
H
65
SLOP OIL
Liquid
1000
16.50
270.00
-
-
19.00
350.00
-
H
33.77
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
3"
SLP
011
076012
103CH2S
3"-SLP-011076012-103CH2S-H
Plug
-
-
H
65
SLOP OIL
Liquid
1000
16.50
270.00
-
-
19.00
350.00
-
H
33.77
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480219
2"
SLP
011
076012
103CH2S
UC
3"-SLP-011076012-103CH2S-H
-
-
H
65
SLOP OIL
Liquid
1000
16.50
270.00
-
-
19.00
350.00
-
H
33.77
NFS
YES
N or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITION: 0,5 BARA (HALF VACUUM) @ 150ºC
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITION: 0,5 BARA (HALF VACUUM) @ 150ºC
if insulated N or Q SA-JER-DS011-TRJR-480219
-
SLP
011
076601
103CH2S
011-D-0018
TRIM
-
-
H
-
-
-
-
0.20
200.00
-
-
3.50
400.00
-
Visual Test
0.00
NFS
YES
SA-JER-DS011-TRJR-480219
2"
SLP
011
076601
103CH2S
011-PI-0293
011-D-0018
-
-
H
50
-
-
-
0.20
200.00
-
-
3.50
400.00
-
H
8.13
NFS
YES
SA-JER-DS011-TRJR-380001
if NOT insulated B or Q if insulated N or Q if NOT insulated B or Q
Page 154 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
INSULATION (NOTE 2)
UNIT
NUMBER
LINE CLASS
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7) if insulated N or Q
SA-JER-DS011-TRJR-480219
2"
SLP
011
076601
103CH2S
011-D-0018
011-LT-0106
-
-
H
50
-
-
-
0.20
200.00
-
-
3.50
400.00
-
H
8.13
NFS
YES
SA-JER-DS011-TRJR-480219
2"
SLP
011
076601
103CH2S
011-D-0018
011-LG-0087
-
-
H
50
-
-
-
0.20
200.00
-
-
3.50
400.00
-
H
8.13
NFS
YES
SA-JER-DS011-TRJR-480219
2"
SLP
011
076601
103CH2S
011-D-0018
011-LT-0088
-
-
H
50
-
-
-
0.20
200.00
-
-
3.50
400.00
-
H
8.13
NFS
YES
SA-JER-DS011-TRJR-480219
2"
SLP
011
076601
103CH2S
011-D-0018
011-LG-0087
-
-
H
50
-
-
-
0.20
200.00
-
-
3.50
400.00
-
H
8.13
NFS
YES
SA-JER-DS011-TRJR-480219
2"
SLP
011
076601
103CH2S
011-D-0018
011-LT-0088
-
-
H
50
-
-
-
0.20
200.00
-
-
3.50
400.00
-
H
8.13
NFS
YES
SA-JER-DS011-TRJR-480219
2"
SLP
011
076601
103CH2S
011-PT-0294
011-D-0018
-
-
H
50
-
-
-
0.20
200.00
-
-
3.50
400.00
-
H
8.13
NFS
YES
SA-JER-DS011-TRJR-480219
2"
SLP
011
076601
103CH2S
011-D-0018
011-LT-0106
-
-
H
50
-
-
-
0.20
200.00
-
-
3.50
400.00
-
H
8.13
NFS
YES
if NOT insulated B or Q if insulated N or Q if NOT insulated B or Q if insulated N or Q if NOT insulated B or Q if insulated N or Q if NOT insulated B or Q if insulated N or Q if NOT insulated B or Q if insulated N or Q if NOT insulated B or Q if insulated N or Q if NOT insulated B or Q
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITION: 0,5 BARA (HALF VACUUM) @ 150ºC
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITION: 0,5 BARA (HALF VACUUM) @ 150ºC
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITION: 0,5 BARA (HALF VACUUM) @ 150ºC
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITION: 0,5 BARA (HALF VACUUM) @ 150ºC
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITION: 0,5 BARA (HALF VACUUM) @ 150ºC
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITION: 0,5 BARA (HALF VACUUM) @ 150ºC
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITION: 0,5 BARA (HALF VACUUM) @ 150ºC
SA-JER-DS011-TRJR-480232
4"
SLP
011
078001
103CH2S
011-G-0025-A
SA-JER-DS011-TRJR-480136
-
-
P
25
SLOP OIL
Liquid
916
9.40
170.00
-
-
22.00
200.00
-
H
33.00
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480232
3/4"
SLP
011
078001
103CH2S
4"-SLP-011078001-103CH2S-P
011-PI-0285
-
-
P
25
SLOP OIL
Liquid
916
9.40
170.00
-
-
22.00
200.00
-
H
33.00
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480232
3/4"
SLP
011
078001
103CH2S
011-PT-0343
4"-SLP-011078001-103CH2S-P
-
-
P
25
SLOP OIL
Liquid
916
9.40
170.00
-
-
22.00
200.00
-
H
33.00
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480232
4"
SLP
011
078001
103CH2S
4"-SLP-011078001-103CH2S-P
Blind flange
-
-
P
25
SLOP OIL
Liquid
916
9.40
170.00
-
-
22.00
200.00
-
H
33.00
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480232
1"
SLP
011
078001
103CH2S
4"-SLP-011078001-103CH2S-P
Blind flange
-
-
P
25
SLOP OIL
Liquid
916
9.40
170.00
-
-
22.00
200.00
-
H
33.00
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
4"
SLP
011
078001
103CH2S
SA-JER-DS011-TRJR-480232
4"-SLP-011099001-103CS1P-S
-
-
P
25
SLOP OIL
Liquid
916
9.40
170.00
-
-
22.00
200.00
-
H
33.00
NFS
YES
Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480232
10"
SLP
011
078601
101CH2S
011-D-0014
TRIM
-
-
N
-
-
-
-
0.50
25.00
-
170.00
3.50
200.00
-
Visual Test
0.00
NFS
YES
BURIED PIPE
Y
POTENTIAL
N
N
N
N
-
RECOMMENDED TO USE INTERTHERM 228 OR SIMILAR
SA-JER-DS011-TRJR-480232
-
SLP
011
078602
103CH2S
011-D-0014
TRIM
-
-
N
-
-
-
-
0.50
170.00
-
-
3.50
200.00
-
Visual Test
0.00
NFS
YES
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 bara (HALF VACUUM) @ 150ºC.
SA-JER-DS011-TRJR-480136
14"
SLP
011
098001
103CS1P
011-E-0037-B
Reducer
S
41
H
40
SLOP OIL
Liquid
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
14"
SLP
011
098001
103CS1P
011-E-0037-D
Reducer
S
41
H
40
SLOP OIL
Liquid
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
2"
SLP
011
098001
103CS1P
14"-SLP-011098001-103CS1P-S
011-TI-0033
S
41
H
25
SLOP OIL
Liquid
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
14"-SLP-011098001-103CS1P-S
011-TI-0040
S
41
H
25
SLOP OIL
Liquid
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
41
H
40
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
if insulated N or Q if NOT insulated B or Q
SA-JER-DS011-TRJR-480136
2"
SLP
011
098001
103CS1P
SA-JER-DS011-TRJR-480136
16"
SLP
011
098001
103CS1P
Reducer
IP-1313-L
S
SLOP OIL
Liquid
SA-JER-DS011-TRJR-480136
3/4"
SLP
011
098001
103CS1P
011-PI-0321
16"-SLP-011098001-103CS1P-S
S
41
H
25
SLOP OIL
Liquid
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
16"
SLP
011
098001
103CS1P
Reducer
16"-SLP-011098001-103CS1P-S
S
41
H
40
SLOP OIL
Liquid
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
2"
SLP
011
098001
103CS1P
16"-SLP-011098001-103CS1P-S
Blind flange
S
41
H
25
SLOP OIL
Liquid
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
6"
SLP
011
098002
103CS1P
IP-1312-L
011-ZV-0120
-
-
N
-
SLOP OIL
Liquid
880
3.20
43.00
-
-
30.00
88.00
-
H
45.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
6"
SLP
011
098002
103CS1P
011-ZV-0120
SA-JER-DS011-TRJR-480001
-
-
N
-
SLOP OIL
Liquid
880
3.20
43.00
-
-
20.00
88.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480001
6"
SLP
011
098002
103CS1P
SA-JER-DS011-TRJR-480134
Reducer
-
-
N
-
SLOP OIL
Liquid
880
3.20
43.00
-
-
20.00
88.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480001
3"
SLP
011
098002
103CS1P
Reducer
Reducer
-
-
N
-
SLOP OIL
Liquid
880
3.20
43.00
-
-
20.00
88.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
SA-JER-DS011-TRJR-480001
6"
SLP
011
098002
103CS1P
Reducer
6"-SLP-011098002-103CS1P-N
-
-
N
-
SLOP OIL
Liquid
880
3.20
43.00
-
-
20.00
88.00
-
H
30.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480001
6"
SLP
011
098002
103CS1P
6"-SLP-011098002-103CS1P-N
Reducer
-
-
N
-
SLOP OIL
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR BLOCKED OUTLET: 43º C. NOTE 6
SA-JER-DS011-TRJR-480001
8"
SLP
011
098002
103CS1P
Reducer
18"-CRU-011098001-103CS1P-N
-
-
N
-
SLOP OIL
Liquid
874
2.00
40.00
-
-
16.50
80.00
-
H
24.75
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
MAX. TEMPERATURE FOR BLOCKED OUTLET: 43º C. NOTE 6
SA-JER-DS011-TRJR-480136
8"
SLP
011
098003
103CS1P
HEADER
IP-1333-L
S
41
H
40
SLOP OIL
Liquid
846
6.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
3/4"
SLP
011
098003
103CS1P
8"-SLP-011098003-103CS1P-S
Plug
S
41
H
25
SLOP OIL
Liquid
846
6.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
3/4"
SLP
011
098003
103CS1P
8"-SLP-011098003-103CS1P-S
011-PI-0496
S
41
H
25
SLOP OIL
Liquid
846
6.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
3/4"
SLP
011
098004
103CS1P
6"-SLP-011098002-103CS1P-N
Reducer
-
-
N
-
SLOP OIL
Liquid
880
3.20
43.00
-
-
30.00
88.00
-
H
45.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
2"
SLP
011
098004
103CS1P
Reducer
2"-CLD-011098316-101CH2S-P
-
-
N
-
SLOP OIL
Liquid
880
3.20
43.00
-
-
30.00
88.00
-
H
45.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480134
3/4"
SLP
011
098004
103CS1P
6"-SLP-011098002-103CS1P-N
3/4"-SLP-011098004-103CS1P-N
-
-
N
-
SLOP OIL
Liquid
880
3.20
43.00
-
-
30.00
88.00
-
H
45.00
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
2"
SLP
011
098005
103CS1P
16"-SLP-011098001-103CS1P-S
2"-CLD-011098315-101CH2S-P
S
41
H
25
SLOP OIL
Liquid
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
2"
SLP
011
098005
103CS1P
2"-SLP-011098005-103CS1P-S
Blind flange
S
41
H
25
SLOP OIL
Liquid
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
2"
SLP
011
098005
103CS1P
16"-SLP-011098001-103CS1P-S
2"-SLP-011098005-103CS1P-S
S
41
H
25
SLOP OIL
Liquid
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
8"
SLP
011
098010
103CS1P
16"-SLP-011098001-103CS1P-S
8"-SLP-011098003-103CS1P-S
S
41
H
40
SLOP OIL
Liquid
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
2"
SLP
011
098011
103CS1P
14"-SLP-011098001-103CS1P-S
2"-CLD-011098320-101CH2S-P
S
41
H
25
SLOP OIL
Liquid
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
2"
SLP
011
098011
103CS1P
2"-SLP-011098011-103CS1P-S
UC
S
41
H
25
SLOP OIL
Liquid
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
2"
SLP
011
098013
103CS1P
14"-SLP-011098001-103CS1P-S
2"-CLD-011098323-101CH2S-P
S
41
H
25
SLOP OIL
Liquid
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
2"
SLP
011
098013
103CS1P
2"-SLP-011098013-103CS1P-S
UC
S
41
H
25
SLOP OIL
Liquid
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
2"
SLP
011
098016
103CS1P
UC
Insul Brk
-
-
P
25
SLOP OIL
Liquid
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC
SA-JER-DS011-TRJR-480136
3/4"
SLP
011
098016
103CS1P
2"-SLP-011098016-103CS1P-P
Plug
-
-
P
25
SLOP OIL
Liquid
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC
SA-JER-DS011-TRJR-480136
2"
SLP
011
098016
103CS1P
Insul Brk
14"-SLP-011098001-103CS1P-S
S
41
H
25
SLOP OIL
Liquid
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC
SA-JER-DS011-TRJR-480136
2"
SLP
011
098017
103CS1P
UC
Insul Brk
-
-
P
25
SLOP OIL
Liquid
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC
SA-JER-DS011-TRJR-480136
3/4"
SLP
011
098017
103CS1P
2"-SLP-011098017-103CS1P-P
Plug
-
-
P
25
SLOP OIL
Liquid
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC
SA-JER-DS011-TRJR-480136
2"
SLP
011
098017
103CS1P
Insul Brk
14"-SLP-011098001-103CS1P-S
S
41
H
25
SLOP OIL
Liquid
846
7.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
ALTERNATE DESIGN CONDITIONS FV @ 290 ºC
SA-JER-DS011-TRJR-480136
2"
SLP
011
098018
103CS1P
8"-SLP-011098003-103CS1P-S
2"-CLD-011098325-101CH2S-P
S
41
H
25
SLOP OIL
Liquid
846
6.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
2"
SLP
011
098018
103CS1P
2"-SLP-011098018-103CS1P-S
Blind flange
S
41
H
25
SLOP OIL
Liquid
846
6.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
2"
SLP
011
098018
103CS1P
8"-SLP-011098003-103CS1P-S
2"-SLP-011098018-103CS1P-S
S
41
H
25
SLOP OIL
Liquid
846
6.00
50.00
-
-
30.00
155.00
-
H
45.00
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
12"
SLP
011
098019
103CS1P
16"-SLP-011099001-103CS1P-S
Insul Brk
S
41
H
40
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
12"
SLP
011
098019
103CS1P
Insul Brk
SA-JER-DS011-TRJR-480002
-
-
H
40
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
3/4"
SLP
011
098019
103CS1P
12"-SLP-011098019-103CS1P-H
Plug
-
-
H
25
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480002
12"
SLP
011
098019
103CS1P
SA-JER-DS011-TRJR-480136
16"-CRU-011001005-106CS1P-H
-
-
H
40
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
2"
SLP
011
098019
103CS1P
2"-FLO-011098302-101CS1P-N
Insul Brk
-
-
P
25
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
3/4"
SLP
011
098019
103CS1P
2"-SLP-011098019-103CS1P-P
Plug
-
-
P
25
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
2"
SLP
011
098019
103CS1P
Insul Brk
12"-SLP-011098019-103CS1P-H
-
-
H
25
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
Y
POTENTIAL
N
N
N
N
-
STEAM OUT CONDITIONS: 0.5 bara @ 150ºC.
NOTE 6
if insulated M or Q SA-JER-DS011-TRJR-480136
-
011
098602
099001
106CS1P
011-E-0037-A/B/C/D
TRIM
-
-
-
H
-
N
-
-
-
-
7.00
82.00
-
-
30.00
210.00
-
Visual Test
0.00
NFS
By Code
if NOT insulated B or Q
103CS1P
6"-DIE-011037006-103CS1P-N
Insul Brk
-
SLOP OIL
Liquid
862.5
7.50
50.00
-
-
28.30
80.00
-
H
42.45
NFS
By Code
A or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
6"
SLP
011
099001
103CS1P
Insul Brk
Reducer
S
41
H
40
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480136
16"
SLP
011
099001
103CS1P
SA-JER-DS011-TRJR-480138
Reducer
S
41
H
40
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
6"
SLP
011
099001
103CS1P
6"-HFO-011025002-103CS1P-N
16"-SLP-011099001-103CS1P-S
S
41
H
40
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-380001
SLP
011
SA-JER-DS011-TRJR-480138
SA-JER-DS011-TRJR-480138
6"
SLP
Page 155 of 155 CLIENT:
SAUDI ARAMCO -TOTAL
LOCATION:
AL-JUBAIL
PROJECT:
SATORP
JOB NO.:
2020
LINE LIST CRUDE DISTILLATION UNIT TRAIN 1 UNIT (011)
LINE IDENTIFICATION REV
P&ID NUMBER
DIAM SERVICE (in) CODE (NOTE 8) (NOTE 9)
TRACING/ JACKETING (NOTE 1)
LINE ROUTING
UNIT
NUMBER
LINE CLASS
INSULATION (NOTE 2)
FROM
TO
TYPE
TEMP. (ºC)
TYPE
THICKNESS (mm)
FLUID
PHASE
DOC. No.
DENSITY (kg/m3)
OPERATING CONDITIONS
DESIGN CONDITIONS
ALTERNATE CONDITIONS
(NOTE 3)
(NOTE 4)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
PRESS. (BARG)
TEMP. (ºC)
STRESS TEMP
TEST CONDITIONS
FLUID CATEGORY (ASME B.31.3)
(ºC)
MEDIUM (NOTE 5)
PRESS. (BARG)
(NOTE 6)
SA-JER-DS011-TRJR-380001
Rev
05
Date:
14-MAY-2013
PWHT REQUIRED
PAINT & COATING
VOC
HAP
H2 SERVICE
TOXIC
LETHAL
BENCENE
SUPPLY BY REMARKS
(NOTE 7)
SA-JER-DS011-TRJR-480136
4"
SLP
011
099001
103CS1P
4"-SLP-011078001-103CH2S-P
16"-SLP-011099001-103CS1P-S
S
41
H
40
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
8"
SLP
011
099001
103CS1P
8"-NAP-011098003-103CH2S-N
16"-SLP-011099001-103CS1P-S
S
41
H
40
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
2"
SLP
011
099001
103CS1P
16"-SLP-011099001-103CS1P-S
011-TT-0449
S
41
H
25
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
8"
SLP
011
099001
103CS1P
8"-JET-011098001-103CS1P-N
16"-SLP-011099001-103CS1P-S
S
41
H
40
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
6"
SLP
011
099001
103CS1P
6"-DIE-011098009-103CS1P-N
16"-SLP-011099001-103CS1P-S
S
41
H
40
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
1/2"
SLP
011
099001
103CS1P
011-FE-0162
011-FT-0162
S
41
H
25
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
16"
SLP
011
099001
103CS1P
16"-SLP-011099001-103CS1P-S
Reducer
S
41
H
40
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
1/2"
SLP
011
099001
103CS1P
011-FE-0162
011-FT-0162
S
41
H
25
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
14"
SLP
011
099001
103CS1P
Reducer
011-E-0037-A
S
41
H
40
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
2"
SLP
011
099001
103CS1P
14"-SLP-011099001-103CS1P-S
Blind flange
S
41
H
25
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
2"
SLP
011
099001
103CS1P
14"-SLP-011099001-103CS1P-S
Blind flange
S
41
H
25
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
14"
SLP
011
099001
103CS1P
Reducer
011-E-0037-C
S
41
H
40
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
6"
SLP
011
099001
103CS1P
6"-SLP-011076001-103CH2S-P
Reducer
S
41
H
40
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480136
16"
SLP
011
099001
103CS1P
Reducer
16"-SLP-011099001-103CS1P-S
S
41
H
40
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480138
16"
SLP
011
099001
103CS1P
Reducer
SA-JER-DS011-TRJR-480136
S
41
H
40
SLOP OIL
Liquid
862.5
7.00
82.00
-
-
30.00
300.00
-
H
50.71
NFS
By Code
M or Q
Y
POTENTIAL
N
N
N
N
-
NOTE 6.
SA-JER-DS011-TRJR-480132
6"
STW
011
098001
101CS2P
IP-1309-L
SA-JER-DS011-TRJR-480112
-
-
N
-
STRIPPED SOUR WATER
Liquid
990
5.00
45.00
-
-
17.30
95.00
-
H
25.95
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
6"
STW
011
098001
101CS2P
SA-JER-DS011-TRJR-480132
Reducer
-
-
N
-
STRIPPED SOUR WATER
Liquid
990
5.00
45.00
-
-
17.30
95.00
-
H
25.95
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
3"
STW
011
098001
101CS2P
Reducer
Reducer
-
-
N
-
STRIPPED SOUR WATER
Liquid
990
5.00
45.00
-
-
17.30
95.00
-
H
25.95
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
6"
STW
011
098001
101CS2P
Reducer
6"-STW-011098001-101CS2P-N
-
-
N
-
STRIPPED SOUR WATER
Liquid
990
5.00
45.00
-
-
17.30
95.00
-
H
25.95
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
6"
STW
011
098001
101CS2P
6"-STW-011098001-101CS2P-N
6"-STW-011098002-101CS2P-N
-
-
N
-
STRIPPED SOUR WATER
Liquid
990
1.80
45.00
-
-
3.50
150.00
-
H
5.25
D
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480135
6"
STW
011
098002
101CS2P
IP-1332-L
SA-JER-DS011-TRJR-480112
-
-
N
-
STRIPPED SOUR WATER
Liquid
990
5.00
45.00
-
-
17.30
95.00
-
H
25.95
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
6"
STW
011
098002
101CS2P
SA-JER-DS011-TRJR-480135
Reducer
-
-
N
-
STRIPPED SOUR WATER
Liquid
990
5.00
45.00
-
-
17.30
95.00
-
H
25.95
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
3"
STW
011
098002
101CS2P
Reducer
Reducer
-
-
N
-
STRIPPED SOUR WATER
Liquid
990
5.00
45.00
-
-
17.30
95.00
-
H
25.95
NFS
By Code
A or Q
N
N
N
N
N
N
-
SA-JER-DS011-TRJR-480112
6"
STW
011
098002
101CS2P
Reducer
6"-STW-011098002-101CS2P-N
-
-
N
-
STRIPPED SOUR WATER
Liquid
990
5.00
45.00
-
-
17.30
95.00
-
H
25.95
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480112
6"
STW
011
098002
101CS2P
6"-STW-011098002-101CS2P-N
011-D-0007
-
-
N
-
STRIPPED SOUR WATER
Liquid
990
1.80
45.00
-
-
3.50
150.00
-
H
5.25
D
By Code
A or Q
N
N
N
N
N
N
-
NOTE 6
SA-JER-DS011-TRJR-480135
3/4"
STW
011
098003
101CS2P
6"-STW-011098002-101CS2P-N
3/4"-OLW-011098301-101CS1PN
-
-
N
-
STRIPPED SOUR WATER
Liquid
990
5.00
45.00
-
-
17.30
95.00
-
H
25.95
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-480291
1"
GAS
011
230303
101CS1P
011-ALP-0001
ATM. AT SAFE LOCATION
-
-
N
-
VENT GAS
Gas
-
0.00
27.00
-
-
0.00
150.00
-
Visual Test
0.00
NFS
By Code
A or Q
N
N
N
N
N
N
-
-
SA-JER-DS011-TRJR-380001
-
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 9.
PROCESS BATTERY LIMIT CONDITIONS Document Number
Description
SA-JER-DS011-TRJR-670006
BATTERY LIMIT SUMMARY PROCESS LINES
Rev. 02
ORIGINAL SIGNED IN PROJECT FILE
DOCUMENT No.: SA-JER-DS011-TRJR-670006
REV: 02 Date: 16-FEB-12
TR Project No.: 02020 PAGE 1 OF 2
BATTERY LIMIT SUMMARY PROCESS LINES CRUDE DISTILLATION UNIT TRAIN 1 UNIT 011
This document is also valid for the unit 012
REVISION CONTROL REV. 02 01 00
DATE 16-FEB-12 23-JUL-10 01-DEC-09
DESCRIPTION Approved for Construction Approved for Construction Issued for Review
UNIT
DISCIPLINE CODE
DOCUMENT TYPE
011
PRO
LIS
SYSTEM
Document class: 2 PREPARED BY
REVIEWED BY
APPROVED BY
Hector Carrero
Miguel Angel Castro
Juan Lechuga
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-670005
BATTERY LIMIT SUMMARY PROCESS LINES CRUDE DISTILLATION UNIT TRAIN 1
INTERCONNECTED LINES
LINE INFORMATION R E V I S I O N
UNIT LINE
INTERFACE N.
SERVICE
DOCUMENT No.: SA-JER-DS011-TRJR-670006
FLOWRATE
INTERCONNECTING LINE
OPERATING
DESIGN
PROPERTIES
CONDITIONS
CONDITIONS
AT OP. COND.
PRESS.
UNIT
LINE N°
P&ID
LINE N°
P&ID
FLUID STATE
INTERMITTENT
NORM.
MAXI.
UNITS
TEMP.
(AT GRADE)
PRESS.
TEMP.
DENS.
(AT GRADE)
MOLECULAR
REV: 02 Date: 16-FEB-12
TR Project No.: 02020 PAGE 2 OF 2
INTERFACE DWG
REMARKS
VISC.
INTERFACE TYPE
WEIGHT
barg
°C
barg
°C
kg/m3
cP
02
---
HAGO PA to NHDT U-111
011
14"-HGO-011027003-103CL2P-H
SA-JER-DS011-TRJR-480134
14"-HGO-111018004-103CL2P-H
SA-JER-DS111-TRJR-480042
L
C
665
798
t/h
12.6
309
18.5
340
665
---
0.24
02
---
HAGO PA from NHDT U-111
011
14"-HGO-011098001-103CL2P-H
SA-JER-DS011-TRJR-480134
14"-HGO-111011001-103CL2P-H
SA-JER-DS111-TRJR-480043
L
C
665
798
t/h
10.1
289
18.5
340
683
---
0.28
02
---
LAGO PA to NHDT U-111
011
16"-LGO-011010001-103CS1P-H
SA-JER-DS011-TRJR-480140
16"-LGO-111018003-103CS1P-H
SA-JER-DS111-TRJR-480042
L
C
701
841
t/h
10.6
229
17.0
275
675
---
0.28
02
---
LAGO PA from NHDT U-111
011
16"-LGO-011098001-103CS1P-H
SA-JER-DS011-TRJR-480140
16"-LGO-111014001-103CS1P-H
SA-JER-DS111-TRJR-480042
L
C
701
841
t/h
8.1
201
17.0
275
708
---
0.30
02
IP 1302 L
LAGO to LP HDS U-101
011
6"-LGO-011025003-103CS1P-N
SA-JER-DS011-TRJR-480133
6"-DIE-6911020001-103CS1X-N
SA-JER-DS691-TPIT-481002
L
C
108
120
t/h
7.0
50
20.0
80
810
---
1.80
01
IP 1303 L
VACUUM RESIDUE to COKER U-021
011
10"-RES-011010003-103CS1P-S
SA-JER-DS011-TRJR-480137
10"-HFO-691102002-103CS1P-S
SA-JER-DS691-TPIT-481002
L
C
315
358
t/h
10.2
205
28.0
235
956
---
182.0
02
IP 1304 L
HOT HVGO to MHC/DHC U-041/051
011
12"-HGO-011038004-103CS1P-S
SA-JER-DS011-TRJR-480137
12"-HFO-691102003-103CS1P-S
SA-JER-DS691-TPIT-481002
L
C
255
284
t/h
13.3
160
30.0
210
857
---
2.74
NOTE 14
02
IP 1305 L
WILD NAPHTHA from HDS U-091/101
011
3"-NPH-011098001-103CH2S-P
SA-JER-DS011-TRJR-480135
3"-NAP-6911010001-103CH1S-P
SA-JER-DS691-TPIT-481002
L
C
8.5
10.8
t/h
5.0
70
18.4
120
615-658
---
0,21-0,30
NOTE 9
01
IP 1306 L
RICH AMINE to ARU U-201/202
011
3"-AMN-011036004-103CH2S-P
SA-JER-DS011-TRJR-480137
3"-AMR-691102002-103CH2SX-P
SA-JER-DS691-TPIT-481002
L
C
8
9.6
t/h
6.0
71
13.0
150
1045
---
0.60
02
IP 1307 L
LEAN AMINE from ARU U-201/202
011
3"-AMN-011099001-103CS2D-H
SA-JER-DS011-TRJR-480137
3"-AML-691102004-103CS2DX-H
SA-JER-DS691-TPIT-481002
L
C
8
9.6
t/h
10.6
65
24.0
100
1010
---
0.81
01
IP 1308 L
SOUR WATER to SWS U-212/213
011
8"-SRW-011044002-106CH2S-P
SA-JER-DS011-TRJR-480132
8"-AWS-691102003-106CH2SX-N
SA-JER-DS691-TPIT-481002
L
C
77
77
t/h
7.0
56
54.7
150
980
---
0.55
02
IP 1309 L
NOT PHENOLIC STRIPPED WATER FROM SWS U-212/213
011
6"-WST-011098001-101CS2P-N
SA-JER-DS011-TRJR-480132
6"-STW-691102004-101CS2P-N
SA-JER-DS691-TPIT-481002
L
C
105
105
t/h
5.0
45
17.3
95
990
---
0.60
NOTE 1
02
IP 1310 L
HAGO+LVGO to HP HDS U-091
011
8"-HGO-011025003-103CS1P-N
SA-JER-DS011-TRJR-480132
8"-DIE-691102002-103CS1X-N
SA-JER-DS691-TPIT-481002
L
C
141.5
157.2
t/h
7.5
50
28.3
80
854
---
4,92
NOTE 11
02
IP 1314 L
CRUDE OIL from STORAGE U-661
011
18"-CRD-011098001-101CS1P-N
SA-JER-DS011-TRJR-480133
18"-CRU-691201002-101CS1X-N
SA-JER-DS691-TPIT-481020
L
C
1179
1179
t/h
2.0
40
16.5
80
874
---
30.0
NOTE 3, 5
02
IP 1313 L
SLOP AND CDU/VDU LONG RECIRCULATION
011
16"-SLP-011098001-103CS1P-S
SA-JER-DS011-TRJR-480136
16"-SLP-691201031-103CS1X-S
SA-JER-DS691-TPIT-481021
L
I
-
707
t/h
7.0
50
30.0
155
846
---
10.0
NOTE 7
01
IP 1315 L
LAGO to STORAGE U-661
011
6"-LGO-011025002-103CS1P-N
SA-JER-DS011-TRJR-480133
6"-DIE-691206014-103CS1X-N
SA-JER-DS691-TPIT-481027
L
C
12
120
t/h
7.0
50
23.3
80
810
---
1.80
02
IP 1316 L
HAGO+LVGO to STORAGE U-661
011
10"-HGO-011098006-103CS1P-H
SA-JER-DS011-TRJR-480132
10"-DIE-691206007-103CS1X-N
SA-JER-DS691-TPIT-481027
L
C
7.4
157.2
t/h
7.0
50
28.3
80
854
---
4,92
01
IP 1317 L
KEROSENE to STORAGE U-661
011
8"-KER-011025002-103CS1P-N
SA-JER-DS011-TRJR-480133
8"-JET-691206003-103CS1X-N
SA-JER-DS691-TPIT-481026
L
C
13
141
t/h
7.0
43
23.3
80
763
---
1.11
02
IP 1318 L
HVGO to STORAGE U-661
011
8"-HGO-011038005-103CS1P-S
SA-JER-DS011-TRJR-480138
8"-HFO-691207006-103CS1P-S
SA-JER-DS691-TPIT-481028
L
C
28
284
t/h
7.0
90
30.0
155
895
---
12.7
02
IP 1319 L
VACUUM RESIDUE to STORAGE U-661
011
16"-RES-011040006-103CS1P-S
SA-JER-DS011-TRJR-480138
16"-HFO-691208009-103CS1P-S
SA-JER-DS691-TPIT-481029
L
C
35
358
t/h
7.0
180
28.0
208
968
---
467
NOTE 10
NOTE 6
NOTE 7
01
---
NAPHTHA to NHDT U-111
011
8"-NPH-011021002-103CS1P-N
SA-JER-DS011-TRJR-480140
8"-NPH-111021002-103CS1P-N
SA-JER-DS111-TRJR-480043
L
C
152
175
t/h
7.0
43
28.0
95
650
---
1.80
02
IP 1301 L
KEROSENE to LP HDS U-101
011
8"-KER-011025001-103CS1P-H
SA-JER-DS011-TRJR-480135
8"-JET-691102001-103CS1X-H
SA-JER-DS691-TPIT-481002
L
C
120
141
t/h
7.0
70
20.0
175
747
---
0.85
01
IP 1311 L
BRINE to WWT U-651
011
6"-BRN-011042003-101CS4P-N
SA-JER-DS011-TRJR-480132
6"-BRN-691102001-101CS4P-N
SA-JER-DS691-TPIT-481002
L
C
95
95
t/h
9.0
42
16.0
80
992
---
0.64
02
IP 1312 L
U 681 SLOP from STORAGE U-681
011
6"-SLP-011098002-103CS1P-N SLP 011098002 103CS1P N 6
SA JER DS011 TRJR 480134 SA-JER-DS011-TRJR-480134
6"-SLP-691201030-103CS1X-N SLP 691201030 103CS1X N 6
SA JER DS691 TPIT 481021 SA-JER-DS691-TPIT-481021
L
C
59
65
t/h
32 3.2
43
30 0 30.0
88
610 970 610-970
---
20 0 20.0
02
IP 1332 L
PHENOLIC STRIPPED WATER from SWS U-211
011
6"-WST-011098002-101CS2P-N
SA-JER-DS011-TRJR-480135
6"-STW-691102007-101CS2P-N
SA-JER-DS691-TPIT-481002
L
C
105
105
t/h
5.0
45
17.3
95
990
---
0.60
02
IP 1333 L
SLOP to 681-T-0001 A/B U-681
011
8"-SLP-011098003-103CS1P-S
SA-JER-DS011-TRJR-480136
8"-SLP-691201019-103CS1X-S
SA-JER-DS691-TPIT-481021
L
I
-
95
t/h
6.0
50
30.0
155
846
---
10.0
NNF
NOTE 7
02
IP 1320 L
FLUSHING OIL
011
6"-FLO-011077301-101CS1P-N
SA-JER-DS011-TRJR-480225
6"-FLO-691217001-101CS1X-N
SA-JER-DS691-TPIT-481038
L
I
-
80
t/h
12.0
50
18.3
80
850
---
3.10
NNF
NOTE 12
GENERAL NOTES: A) MAXI FLOWRATES REFER TO HIGHEST NORMAL FLOWRATE OF ALL OPERATING CASES. B) DESIGN CONDITIONS TO BE CONFIRMED, BASED ON INTERCONNECTING FINALIZATION.
02 02 01 02 02 02 02 01 02 02 02 02 02 02 02
NOTES: 1) NOT PHENOLIC STRIPPED WATER EXITS ONLY FOR UNIT 011 AN NOT FOR UNIT 012. OSBL DENSITY: 992 Kg/m3. 2) DELETED 3) B.L. PRESSURE AT GRADE LEVEL. INDICATED VALUES AS PER MINUTE OF MEETING Nº MM.- JER-35257-MOM-TRJR-DSTP-000007. 4) OSBL DESIGN PRESSURE 30 BARG SHALL BE EXTENDED UNTIL LAST ZV AT BATTERY LIMIT DUE TO SURGE ANALYSIS. ISBL DESIGN PRESSURE WILL BE 21,8 BARG ACCORDING LETTER JER-35257-LET-TRJR-DSTP-2012-001692. 5) OSBL DESIGN PRESSURE 16.5 BARG SHALL BE EXTENDED UNTIL LAST ZV AT BATTERY LIMIT DUE TO SURGE ANALYSIS. ISBL DESIGN PRESSURE HAS BEEN INCREASED UP TO 16.5 BARG TO PROTECT SUCTION OF THE PUMP IN CASE OF ZV-0087 CLOSING. SEE JER-35257-MOM-TRJR-DSTP-000351. OPERATING CASE: 30 ºC, DENSITY: 880 KG/M3, VISCOSITY:48 cP. 6) OSBL DESIGN PRESSURE AND TEMPERATURE, 28.4 BARG AND 118°C RESPECTIVELY, SHALL BE EXTENDED UNTIL LAST ZV AT BATTERY LIMIT DUE TO SURGE ANALYSIS. ISBL DESIGN PRESSURE AND TEMPERATURE WILL BE 28.3 BARG AND 80°C. VISCOSITY: 4.92-5.63 Cp. FULL VACCUUM DUE TO SURGE ANALYSIS. 7) DESIGN TEMPERATURE CORRESPOND TO THE SATURATION TEMPERATURE OF STEAM TRACING. 8) OSBL DESIGN TEMPERATURE: 273 ºC. 3
9) OSBL: 615 kg/m /0.21-0.3 Cp 10) OSBL DESIGN AND OPERATING TEMPERATURE, 68 ºC AND 95 ºC RESPECTIVELY. 11) OSBL VISCOSITY: 4.92-5.63 cP. 12) OSBL VISCOSITY: 2.9/4.3 cP, DENSITY: 810 KG/M3. 13) OSBL DENSITY: 992 KG/M3. 14) OSBL OPERATING PRESSURE HAS BEEN INCREASED UP TO 13.3 BARG ACCORDING IQ Nº JER-IQR-TRJR-TPIT-L-0038
NOTE 8
2 4 NOTE 2, NOTE 13
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 10.
UTILITIES BATTERY LIMIT CONDITIONS Document Number
Description
SA-JER-DS011-TRJR-670007
BATTERY LIMIT SUMMARY UTILITY LINES
Rev. 02
ORIGINAL SIGNED IN PROJECT FILE
DOCUMENT No.: SA-JER-DS011-TRJR-670007
REV: 02 Date: 16-FEB-12
TR Project No.: 02020 PAGE 1 OF 2
BATTERY LIMIT SUMMARY UTILITY LINES CRUDE DISTILLATION UNIT TRAIN 1 UNIT 011
This document is also valid for the unit 012
REVISION CONTROL REV. 02 01 00
DATE 16-FEB-12 23-JUL-10 01-DEC-09
DESCRIPTION Approved for Construction Approved for Construction Issued for Review
UNIT
DISCIPLINE CODE
DOCUMENT TYPE
011
PRO
LIS
SYSTEM
Document class: 2 PREPARED BY Hector Carrero
REVIEWED BY Miguel Angel Castro
APPROVED BY Juan Lechuga
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
BATTERY LIMIT SUMMARY UTILITY LINES CRUDE DISTILLATION UNIT TRAIN 1
INTERCONNECTED LINES
LINE INFORMATION R E V I S I O N
UNIT LINE
INTERFACE N.
DOCUMENT No.: SA-JER-DS011-TRJR-670007
FLOWRATE
INTERCONNECTING LINE
OPERATING
DESIGN
PROPERTIES
CONDITIONS
CONDITIONS
AT OP. COND.
PRESS.
SERVICE UNIT
LINE N°
P&ID
LINE N°
P&ID
FLUID STATE
INTERMITTENT
NORM.
MAXI.
UNITS
TEMP.
(AT GRADE)
PRESS.
TEMP.
DENS.
(AT GRADE)
barg
°C
MOLECULAR
REV: 02 Date: 16-FEB-12
VISC.
INTERFACE DWG
INTERFACE TYPE
TR Project No.: 02020 PAGE 2 OF 2
REMARKS
WEIGHT
barg
°C
kg/m 3
cP
01
IP 1331 L
LPF FROM LP FLARE KO DRUM
011
44"-LPF-011076001-101CH2F-N
SA-JER-DS011-TRJR-480219
44"-LFL-691306319-101CH2F-N
SA-JER-IP691-TPIT-481076
V
I
-
550000
kg/h
0,2
329
3,5
350
----
58,0
0,01
02
IP 1322 L
INSTRUMENT AIR TO CDU/VDU
011
3"-INA-011074301-301CG2P-N
SA-JER-DS011-TRJR-480211
3"-IAI-691302314-301CG1P-N
SA-JER-IP691-TPIT-481071
V
C
583
1089
Nm3/h
8,0
45
12,0
80
----
29,0
0,01
01
IP 1323 L
SERVICE AIR TO CDU/VDU
011
3"-UTA-011074301-301CG2P-N
SA-JER-DS011-TRJR-480211
3"-SAI-691303311-301CG2P-N
SA-JER-IP691-TPIT-481070
V
I
-
210
Nm3/h
7,5
45
12,0
80
----
29,0
0,01
02
IP 1321 L
LOW PRESURE NITROGEN TO CDU/VDU
011
4"-LPN-011074301-101CS1P-N
SA-JER-DS011-TRJR-480211
4"-N2L-691301316-101CS1P-N
SA-JER-IP691-TPIT-481074
V
I
15
240
Nm3/h
9,0
40
12,0
80
----
28,0
0,01
01
IP 1329 L
LOW PRESSURE STEAM TO CDU/VDU
011
20"-LPS-011071301-101CS1P-H
SA-JER-DS011-TRJR-480202
20"-LPS-691314311-101CS1P-H
SA-JER-IP691-TPIT-481066
V
C
52700
57970
kg/h
4,0
160
7,0/FV
290
----
18,0
0,01
01
IP 1328 L
MEDIUM PRESSURE STEAM TO CDU/VDU
011
12" MPS 011071301 103CS1P H 12"-MPS-011071301-103CS1P-H
SA JER DS011 TRJR 480202 SA-JER-DS011-TRJR-480202
12" MPS 691314307 103CS1P H 12"-MPS-691314307-103CS1P-H
SA JER IP691 TPIT 481065 SA-JER-IP691-TPIT-481065
V
C
19600
21560
k /h kg/h
14 5 14,5
250
19 0/FV 19,0/FV
350
----
18 0 18,0
0 01 0,01
01
IP 1324 L
HP BOILER FEED WATER TO CDU/VDU
011
6"-HPW-011071301-106CS1P-H
SA-JER-DS011-TRJR-480202
6"-BFW-691304306-106CS1P-H
SA-JER-IP691-TPIT-481063
L
C
1000
105000
kg/h
60,0
105
90,0
150
954
----
0,27
02
011
3"-CND-011071302-103CS1P-H
SA-JER-DS011-TRJR-480202
3"-CND-691317303-103CS1P-H
SA-JER-IP691-TPIT-481061
L
C
10345
12395
kg/h
11,5
134
29,0
150
931
----
0,20
NOTE 7
40"-CWS-691307306-301FE0P-N
SA-JER-IP691-TPIT-481054
L
C
5568
6128
t/h
6,0
36,5
11,0
80
994
----
0,70
NOTE 4
40"-CWR-691307306-301FE0P-N
SA-JER-IP691-TPIT-481054
L
C
5568
6128
t/h
4,0
46,5
11,0
80
990
----
0,60 0,70
NOTE 5
NOTE 2
IP 1330 L
PUMPED CONDENSATE FROM CDU/VDU
02
IP 6042 S
COOLING WATER SUPPLY TO CDU/VDU
011
40"-CWS-011072301-301FE0W-N
SA-JER-DS011-TRJR-480207
02
IP 6041 S
COOLING WATER RETURN FROM CDU/VDU
011
40"-CWR-011072301-301FE0W-N
SA-JER-DS011-TRJR-480207
02
IP 6040 S
AUXILIARY CW SUPPLY TO CDU/VDU
011
8"-AWS-011080302-301FE0W-N
SA-JER-DS011-TRJR-480237
8"-CWS-691309307-301FE0P-N
SA-JER-IP691-TPIT-481056
L
C
185779
204357
kg/h
5,0
34,5
9,0
80
994
----
02
IP 6039 S
AUXILIARY CW RETURN TO CDU/VDU
011
8"-AWR-011080302-301FE0W-N
SA-JER-DS011-TRJR-480237
8"-CWR-691309307-301FE0P-N
SA-JER-IP691-TPIT-481056
L
C
185779
204357
kg/h
3,0
45
9,0
80
990
----
0,60
01
IP 1325 L
DEMINERALIZED WATER TO CDU/VDU
011
2"-DWA-011071302-101SR0P-N
SA-JER-DS011-TRJR-480202
2"-DWA-691305307-101SR0P-N
SA-JER-IP691-TPIT-481057
L
I
0
2000
kg/h
3,0
35
11,0
80
994
----
0,70
01
IP 6126 S
SERVICE WATER TO CDU/VDU
011
2"-SWA-011073302-301FE0W-N
SA-JER-DS011-TRJR-480209
2"-RWA-691311312-301FE0W-N
SA-JER-IP691-TPIT-481052
L
C
400
7500
kg/h
4,5
35
8,0
80
994
----
0,70
01
IP 5012 S
POTABLE WATER TO CDU/VDU
011
2"-PWA-011073301-301PU0W-N
SA-JER-DS011-TRJR-480209
2"-POW-691310318-301PU0W-N
SA-JER-IP691-TPIT-481053
L
I
0
9200
kg/h
4,0
25
8,0
80
994
----
0,70
NOTE 3
02
IP 1326 L
FUEL GAS TO CDU/VDU
011
12"-FUG-011075301-101CS2P-H
SA-JER-DS011-TRJR-480214
12"-FGS-691313311-101CS2P-H
SA-JER-IP691-TPIT-481067
V
C
9613
11577
kg/h
5,0
52
8,5
80
----
25,9
0,01
NOTE 1
02
IP 1327 L
PILOT GAS TO CDU/VDU
011
2"-PIG-011075302-101CS1P-S
SA-JER-DS011-TRJR-480214
2"-PTG-691313309-101CS1P-S
SA-JER-IP691-TPIT-481068
V
C
81,0
89,1
kg/h
5,0
28.6
8,5
155
----
44,2
0,01
NOTE 6,8
02
IP 1334 L
LOW PRESSURE STEAM FROM UTILITY STATION
011
2"-LPS-011071303-101CS1P-H
SA-JER-DS011-TRJR-480202
2"-LPS-691314311-101CS1P-H
SA-JER-IP691-TPIT-481066
V
C
-
200
kg/h
4,0
160
7,0/FV
290
----
18,0
0,01
GENERAL NOTES:
NOTES: 02 1) MW RANGE : 17 (MIN) - 58 (MAX). LHV RANGE: 10900 kcal/h (MIN) - 11900 kcal/h (MAX), NORMAL LHV = 11340 kcal/h. NORMAL/MAX FLOW RATE ACCORDING TO VENDOR UTILITY CONSUMPTION LIST BASED ON NORMAL FG COMPOSITION. FOR VACUUM HEATER 606,3 KG/H TREATED OFF GAS (5,978 GCAL/H) IS FIRED ADDITIONALLY (NORMAL AND DESIGN). MAXIMUM FUEL GAS PEAK CONSUMPTION IS 13719 KG/H (156,6 GCAL/H) BASED ON NORMAL FG COMPOSITION. 02 2) 8165 Nm3/h PEAK CONSUMPTION FOR ATMOSPHERIC COLUMN VACUUM PROTECTION. PEAK CONSUMPTION ON DESALTING WATER DRUM BLANKETING. 3) TWO EYE SHOWER & SAFETY SHOWER IN OPERATION. 01 4) MAXIMUM FLOWRATE INTO ACCOUNT ALL THE EXCHANGERS OVERDESIGN 10% EXCEPT THE 011-E-0036 THAT HAS 50% OVERDESIGN, ACCORDING TO BASIS OF DESIGN. 01 5) NNF (ONLY PURGE GAS). FOR INFORMATION OF OTHER SCENARIOS, REFER TO DOC. "Flare Load Summary" No.SA-JER-DS011-TRJR-670005 . OPERATING PRESSURE ACCORDING TO BASIC DESIGN DATA JERES C-101. 01 6) DESIGN TEMPERATURE CORRESPOND TO THE SATURATION TEMPERATURE OF STEAM TRACING. 02 7) OSBL DESIGN/OPERATING TEMPERATURE: 200 ºC/165 ºC 02 8) NORMAL/MAX FLOW RATE ACCORDING TO VENDOR UTILITY CONSUMPTION LIST.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 11.
FEED QUALITIES & EXPECTED PRODUCT PROPERTIES
DOCUMENT No.: SA-JER-DS011-TRJR-320001
REV: 02 Date: 05-APR-11
TR Project No.: 02020 Page 18 of 48
APPENDIX 1: SOG File Rev D N° Modified Sample Date Generation Date Name UIF File
Laboratory UTF File Data Source Codes S0000 Brut
DEN API PPT V01 V03 V05 SUL RSH H2S ASP7 CCR ACY RVP KUOP C20M C20V C20D C20A C30M C30V C30D C30A IC4M IC4V IC4D IC4A NC4M NC4V NC4D NC4A IC5M IC5V IC5D IC5A NC5M NC5V NC5D NC5A
Masse volumique 15°C API Point d'Ecoulement Visco à 10 °C Visco à 37.8 °C Visco à 50 °C Soufre Mercaptans dissous H2S Asphaltènes C7 Carbone Conradson Acidité Organique Potentiométrie Tension de Vapeur Reid à 37,8°C KUOP Ethane Poids Ethane Volume Ethane Mv15 Ethane API Propane Poids Propane Volume Propane Mv15 Propane API Iso Butane Poids Iso Butane Volume Iso Butane Mv15 Iso Butane API Normal Butane Poids Normal Butane Volume Normal Butane Mv15 Normal Butane API Iso-Pentane Poids Iso-Pentane Volume Iso-Pentane Mv15 Iso-Pentane API Normal Pentane Poids Normal Pentane Volume Normal Pentane Mv15 Normal Pentane API
1 2 TRUE mars-06 août-03 oct-06 avr-06 Arab Heavy Arab Heavy D:\Totel\Cdr\A H:\Brut_Cda\ rabh.Uif Pf_Update.Xl s Bp/Kbc Flash Assay B/U/N Dest F kg/m3 API °C mm2/s mm2/s mm2/s %pds mg/kg mg/kg %pds %pds mgKOH/g kPa %pds %vol kg/m3 %pds %vol kg/m3 %pds %vol kg/m3 %pds %vol kg/m3 %pds %vol kg/m3 %pds %vol kg/m3 -
N SF ARH 890.0 27.40 -48.0 6.25E+01 1.92E+01 1.30E+01 2.9300 63 0 6.80 8.47 0.20 49.17 11.66 0.030 0.074 358.0 264.43 0.438 0.766 508.0 147.13 0.198 0.312 563.0 119.86 0.875 1.331 584.0 110.80 0.619 0.879 625.0 94.88 1.118 1.572 631.0 92.73
N SF_Old ARH_Old
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-320001
DOCUMENT No.: SA-JER-DS011-TRJR-320001
REV: 02 Date: 05-APR-11
TR Project No.: 02020 Page 19 of 48
APPENDIX 1: SOG File Rev D NIC VAN MYLD CMYLD VYLD CVYLD N2T CPF CPG CPD BPT VEX
Nickel Vanadium Rendement Poids Rendement Poids cumulé Rendement Volume Rendement Volume cumulé Azote Total Pt Coupe Dsv/Rsv Calculé Fzn Pt Coupe Dsv/Rsv Calculé Gps Pt Coupe Dsv/Rsv Calculé Dgs Baril par tonne Expansion Volumique
mg/kg mg/kg %pds %pds %vol %vol %pds °C °C °C -
17.0 53.0 100.000 100.000 100.000 100.000 0.2022 501.2 516.6 535.5 7.0796 0.00
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-320001
DOCUMENT No.: SA-JER-DS011-TRJR-
Coupe
S0003 S0304 S0405 S0506 S0607 S0708 S0809 S0910 S1011 S1112 S1213 S1314 S1415 S1516 S1617 S1718 S1819 S1920 S2021 S2122 S2223 S2324 S2425 S2526 S2627 S2728 S2829 S2930 S3031 S3132 S3233 S3334 S3435 S3536 S3637 S3738 S3839 S3940 S4041 S4142 S4243 S4344 S4445 S4546 S4648 S4850 S5052 S5254 S5456 S5658 S5860 S6000 S9999
Standard PI-36 Standard 36-40 Standard 40-50 Standard 50-60 Standard 60-70 Standard 70-80 Standard 80-90 Standard 90-100 Standard 100-110 Standard 110-120 Standard 120-130 Standard 130-140 Standard 140-150 Standard 150-160 Standard 160-170 Standard 170-180 Standard 180-190 Standard 190-200 Standard 200-210 Standard 210-220 Standard 220-230 Standard 230-240 Standard 240-250 Standard 250-260 Standard 260-270 Standard 270-280 Standard 280-290 Standard 290-300 Standard 300-310 Standard 310-320 Standard 320-330 Standard 330-340 Standard 340-350 Standard 350-360 Standard 360-370 Standard 370-380 Standard 380-390 Standard 390-400 Standard 400-410 Standard 410-420 Standard 420-430 Standard 430-440 Standard 440-450 Standard 450-460 Standard 460-480 Standard 480-500 Standard 500-520 Standard 520-540 Standard 540-560 Standard 560-580 Standard 580-600 Standard 600-PF Brut (recalculated)
ICP Point initial
FCP Point final
DEN Masse volumique à 15°C
Masse volumique à 15°C
°C * 36.0 40.0 50.0 60.0 70.0 80.0 90.0 100.0 110.0 120.0 130.0 140.0 150.0 160.0 170.0 180.0 190.0 200.0 210.0 220.0 230.0 240.0 250.0 260.0 270.0 280.0 290.0 300.0 310.0 320.0 330.0 340.0 350.0 360.0 370.0 380.0 390.0 400.0 410.0 420.0 430.0 440.0 450.0 460.0 480.0 500.0 520.0 540.0 560.0 580.0 600.0 *
°C 36.0 40.0 50.0 60.0 70.0 80.0 90.0 100.0 110.0 120.0 130.0 140.0 150.0 160.0 170.0 180.0 190.0 200.0 210.0 220.0 230.0 240.0 250.0 260.0 270.0 280.0 290.0 300.0 310.0 320.0 330.0 340.0 350.0 360.0 370.0 380.0 390.0 400.0 410.0 420.0 430.0 440.0 450.0 460.0 480.0 500.0 520.0 540.0 560.0 580.0 600.0 * *
kg/m3 589.7 634.6 648.0 665.3 680.3 693.1 703.6 704.5 713.8 722.9 732.0 740.9 749.9 760.9 768.6 774.6 778.6 785.3 792.6 799.6 806.4 812.6 819.1 825.6 831.7 837.3 842.8 849.8 856.9 863.8 870.7 879.0 885.4 891.4 897.0 902.2 906.9 911.1 915.1 918.7 921.8 924.6 931.1 933.4 934.7 948.2 951.6 958.9 969.4 979.5 988.8 1075.2 886.5
t/m3 0.5897 0.6346 0.6480 0.6653 0.6803 0.6931 0.7036 0.7045 0.7138 0.7229 0.7320 0.7409 0.7499 0.7609 0.7686 0.7746 0.7786 0.7853 0.7926 0.7996 0.8064 0.8126 0.8191 0.8256 0.8317 0.8373 0.8428 0.8498 0.8569 0.8638 0.8707 0.8790 0.8854 0.8914 0.8970 0.9022 0.9069 0.9111 0.9151 0.9187 0.9218 0.9246 0.9311 0.9334 0.9347 0.9482 0.9516 0.9589 0.9694 0.9795 0.9888 1.0752 0.8865
REV: 02 Date: 05-APR-11
CPT Point de trouble
PPT Point d'écoulement
SMK Point de fumée
APT Point d'aniline
°C * -126.9 -123.7 -119.1 -114.5 -110.0 -105.4 -100.8 -96.2 -91.6 -87.1 -82.5 -77.9 -73.3 -68.8 -64.2 -59.6 -54.5 -49.0 -43.7 -38.6 -33.8 -29.3 -24.9 -20.8 -17.0 -13.4 -10.0 -6.9 -3.8 -0.9 2.0 4.6 7.1 8.3 8.8 9.3 9.8 10.3 10.8 11.3 11.7 12.2 12.7 13.5 14.5 15.4 16.4 17.4 18.4 19.4 30.5 *
°C * -150.0 -150.0 -138.1 -125.0 -113.8 -103.9 -95.1 -87.3 -80.2 -73.8 -67.9 -62.4 -57.4 -52.7 -48.3 -44.2 -40.4 -36.8 -33.3 -30.1 -27.1 -24.1 -21.4 -18.7 -16.2 -13.8 -11.5 -9.3 -7.1 -5.1 -3.1 -1.2 0.6 2.4 4.1 5.7 7.3 8.9 10.4 11.8 13.2 14.6 15.9 17.8 20.3 22.6 24.8 26.8 28.8 30.7 49.7 *
mm * 5406.8 5404.6 103.0 68.4 56.8 54.9 49.4 44.2 40.1 36.1 33.7 32.6 31.5 30.7 28.9 26.6 25.6 24.8 24.0 23.3 22.7 22.0 21.3 20.7 20.3 19.9 19.2 18.5 17.8 17.2 16.6 16.0 15.5 15.2 14.9 14.7 14.4 14.2 14.0 13.9 13.7 13.4 13.3 13.2 12.6 1.9 0.7 -0.5 -1.2 -1.5 1.4 *
°C * -9.4 -8.4 -6.9 -5.5 -4.1 -2.7 -1.2 0.2 1.6 3.1 4.5 5.9 7.4 8.8 10.2 11.7 13.1 14.5 16.0 17.4 18.9 20.3 21.7 23.1 24.5 26.0 27.4 28.8 30.2 31.5 32.9 34.3 35.7 37.1 38.5 39.8 41.2 42.6 44.0 45.4 46.8 48.2 49.5 51.6 54.4 57.2 59.9 62.7 65.5 68.2 88.3 *
CIT Indice de cétane calculé (ASTM D4737) 92.8 70.1 60.8 51.4 45.4 42.0 40.7 46.5 46.0 45.7 45.5 45.4 45.3 44.0 44.6 46.2 48.7 49.7 50.2 50.9 51.6 52.5 53.1 53.7 54.5 55.4 56.2 56.3 56.2 56.1 56.0 55.2 55.2 55.3 55.5 55.9 56.4 57.1 57.8 58.6 59.6 60.7 60.0 61.2 64.0 61.8 64.4 64.8 63.5 62.1 61.0 -15.7 -7.2
TR Project No.: 02020 Page 20 of 48
CNB Nombre de cétane (ex ASTM D4737)
PAR Paraffines
NAP Naphtènes
ARO Aromatiques
PAW Paraffines
NAW Naphtènes
ARW Aromatiques
2AR Di-aromatiques
3AR Tri-aromatiques
136.1 86.3 69.3 53.9 45.1 40.6 38.9 46.7 46.1 45.6 45.4 45.2 45.0 43.3 44.2 46.3 50.0 51.4 52.1 53.1 54.2 55.6 56.6 57.6 58.7 60.2 61.5 61.6 61.5 61.4 61.2 59.9 59.9 60.1 60.4 61.0 61.8 62.9 64.1 65.5 67.1 69.0 67.8 69.9 74.9 71.0 75.5 76.3 73.9 71.6 69.6 2.2 3.2
%vol 100.00 96.31 94.76 92.05 87.43 83.13 80.46 77.59 75.27 73.66 72.22 71.57 71.42 71.29 71.17 69.35 65.51 64.42 63.81 63.20 62.59 61.98 61.33 60.19 59.62 59.35 59.08 57.86 56.61 55.36 * * * * * * * * * * * * * * * * * * * * * * *
%vol 0.00 3.69 5.24 7.46 11.12 14.46 17.06 18.89 19.97 20.13 19.33 18.53 18.38 18.38 18.39 18.40 18.41 18.42 18.43 18.44 18.45 18.46 18.47 18.48 18.49 18.49 18.50 18.51 18.52 18.53 * * * * * * * * * * * * * * * * * * * * * * *
%vol 0.00 0.00 0.00 0.49 1.45 2.40 2.48 3.52 4.76 6.21 8.45 9.90 10.21 10.32 10.44 12.24 16.08 17.16 17.76 18.36 18.96 19.56 20.20 21.33 21.89 22.15 22.41 23.63 24.87 26.11 27.34 28.58 29.81 31.04 31.56 31.86 32.16 32.46 32.76 33.06 33.36 33.66 33.96 34.26 34.71 35.31 * * * * * * *
%pds 100.00 95.57 93.85 90.72 85.54 80.88 78.23 75.00 72.68 70.90 69.44 68.93 68.55 68.86 68.55 66.65 62.20 61.17 60.83 58.04 57.64 57.22 56.76 55.74 55.38 55.36 55.34 54.28 53.20 52.15 * * * * * * * * * * * * * * * * * * * * * * *
%pds 0.00 4.43 6.15 8.63 12.58 16.06 18.66 20.60 21.49 21.60 20.48 19.39 19.56 19.29 19.57 19.42 19.60 19.45 19.29 19.13 18.98 18.85 18.70 18.57 18.44 18.33 18.21 18.07 17.93 17.80 * * * * * * * * * * * * * * * * * * * * * * *
%pds 0.00 0.00 0.00 0.65 1.88 3.06 3.12 4.41 5.83 7.51 10.08 11.68 11.89 11.85 11.88 13.93 18.20 19.38 19.87 22.83 23.38 23.94 24.53 25.70 26.18 26.32 26.45 27.65 28.86 30.06 31.23 32.34 33.48 34.63 34.99 35.12 35.26 35.43 35.60 35.79 35.99 36.20 36.27 36.50 36.93 37.03 * * * * * * *
%pds 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.44 1.59 2.68 3.71 4.67 5.56 6.32 7.25 8.62 9.54 10.10 10.63 11.15 11.65 12.14 12.61 13.07 13.55 14.04 14.53 15.02 15.51 16.00 16.48 16.97 17.46 17.95 18.68 19.66 20.64 21.62 22.59 23.57 24.55 31.63 15.96
%pds 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.01 0.06 0.11 0.17 0.22 0.27 0.32 0.37 0.46 1.02 1.03 0.74 0.45 1.14 1.83 2.51 3.16 3.81 4.43 5.04 5.67 6.31 6.95 7.60 8.24 8.88 9.52 10.17 10.81 11.45 12.41 13.70 14.98 16.27 17.55 18.84 20.12 29.43 11.86
V04 V05 Viscosité à 40 °C Viscosité à 50 °C
mm2/s * 2.18E-01 2.86E-01 3.83E-01 4.81E-01 5.80E-01 6.79E-01 7.78E-01 8.78E-01 9.78E-01 1.08E+00 1.18E+00 1.28E+00 1.38E+00 1.37E+00 1.38E+00 1.40E+00 1.47E+00 1.55E+00 1.65E+00 1.77E+00 1.92E+00 2.09E+00 2.30E+00 2.55E+00 2.84E+00 3.19E+00 3.62E+00 4.14E+00 4.78E+00 5.57E+00 6.55E+00 7.80E+00 9.29E+00 1.19E+01 1.51E+01 1.93E+01 2.47E+01 3.14E+01 3.98E+01 5.07E+01 6.41E+01 8.04E+01 9.99E+01 1.36E+02 1.85E+02 2.68E+02 4.72E+02 7.83E+02 1.47E+03 3.17E+03 1.60E+09 2.04E+01
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-320001
mm2/s * 2.17E-01 2.76E-01 3.61E-01 4.45E-01 5.30E-01 6.15E-01 6.99E-01 7.84E-01 8.68E-01 9.53E-01 1.04E+00 1.12E+00 1.21E+00 1.21E+00 1.23E+00 1.27E+00 1.31E+00 1.38E+00 1.45E+00 1.55E+00 1.66E+00 1.79E+00 1.95E+00 2.13E+00 2.36E+00 2.62E+00 2.93E+00 3.31E+00 3.77E+00 4.33E+00 5.03E+00 5.89E+00 6.90E+00 8.62E+00 1.08E+01 1.34E+01 1.68E+01 2.08E+01 2.58E+01 3.17E+01 3.89E+01 4.74E+01 5.74E+01 7.57E+01 1.02E+02 1.46E+02 2.44E+02 3.88E+02 6.90E+02 1.39E+03 2.32E+08 1.45E+01
DOCUMENT No.: SA-JER-DS011-TRJR-
Coupe
S0001 S0107 S0114 S0119 S0714 S0719 S1419 S1923 S1423 S2334 S3437 S2337 S1437 S1434 S3746 S4650 S5056 S3756 S3750 S5052 S5254 S5456 S3752 S3754 S3700 S5000 S5200 S5400 S5600
Standard PI-15 Standard 15-75 Standard 15-145 Standard 15-190 Standard 75-145 Standard 75-190 Standard 145-190 Standard 190-230 Standard 145-230 Standard 230-340 Standard 340-375 Standard 230-375 Standard 145-375 Standard 145-340 Standard 375-460 Standard 460-500 Standard 500-560 Standard 375-560 Standard 375-500 Standard 500-520 Standard 520-540 Standard 540-560 Standard 375-520 Standard 375-540 Standard 375-PF Standard 500-PF Standard 520-PF Standard 540-PF Standard 560-PF
ICP Point initial
FCP Point final
DEN Masse volumique à 15°C
Masse volumique à 15°C
°C * 15.0 15.0 15.0 75.0 75.0 145.0 190.0 145.0 230.0 340.0 230.0 145.0 145.0 375.0 460.0 500.0 375.0 375.0 500.0 520.0 540.0 375.0 375.0 375.0 500.0 520.0 540.0 560.0
°C 15.0 75.0 145.0 190.0 145.0 190.0 190.0 230.0 230.0 340.0 375.0 375.0 375.0 340.0 460.0 500.0 560.0 560.0 500.0 520.0 540.0 560.0 520.0 540.0 * * * * *
kg/m3 551.1 648.6 695.6 719.6 722.3 742.4 768.4 796.0 781.3 844.7 892.7 856.0 829.0 817.7 918.7 941.7 961.2 938.8 925.9 951.6 958.9 969.4 929.6 933.2 999.0 1034.4 1041.9 1049.7 1062.9
t/m3 0.5511 0.6486 0.6956 0.7196 0.7223 0.7424 0.7684 0.7960 0.7813 0.8447 0.8927 0.8560 0.8290 0.8177 0.9187 0.9417 0.9612 0.9388 0.9259 0.9516 0.9589 0.9694 0.9296 0.9332 0.9990 1.0344 1.0419 1.0497 1.0629
REV: 02 Date: 05-APR-11
CPT Point de trouble
PPT Point d'écoulement
SMK Point de fumée
APT Point d'aniline
°C * * * * -92.3 -79.9 -67.2 -45.8 -57.1 -14.1 7.0 -8.2 -12.3 -23.8 8.7 14.0 15.7 11.6 9.8 15.4 16.4 17.4 10.3 10.8 24.0 27.3 27.9 28.5 29.5
°C * * * * * * * * * * * -9.0 * * * * * * * * * * * * 36.5 * * * 47.7
mm * 106.6 48.0 39.5 40.0 34.6 29.5 24.4 26.9 19.5 15.5 18.4 21.0 22.2 14.0 12.9 0.4 5.5 13.7 1.9 0.7 -0.5 9.3 7.6 -2.3 -1.1 -0.7 -0.3 0.6
°C * * * * 1.4 4.9 9.1 15.3 12.1 26.1 36.1 28.5 22.9 20.4 44.2 53.1 60.3 52.0 47.0 57.2 59.9 62.7 48.5 49.9 69.4 79.1 80.9 82.7 85.6
CIT Indice de cétane calculé (ASTM D4737) 170.0 51.2 53.2 53.2 45.7 46.6 46.2 50.8 48.5 53.9 55.5 52.8 51.4 51.9 55.7 62.3 60.3 45.2 53.2 64.4 64.8 63.5 51.3 49.1 -15.3 -17.5 -19.7 -24.1 -22.0
TR Project No.: 02020 Page 21 of 48
CNB Nombre de cétane (ex ASTM D4737)
PAR Paraffines
NAP Naphtènes
ARO Aromatiques
PAW Paraffines
NAW Naphtènes
ARW Aromatiques
2AR Di-aromatiques
3AR Tri-aromatiques
392.2 53.7 56.7 56.7 45.7 47.0 46.3 53.1 49.7 57.9 60.3 56.1 53.9 54.7 60.7 71.9 68.3 45.0 56.7 75.5 76.3 73.9 53.8 50.5 2.2 2.2 2.3 2.8 2.5
%vol 100.00 95.03 82.17 78.01 74.87 72.56 69.56 63.51 66.73 * * * * * * * * * * * * * * * * * * * *
%vol 0.00 4.49 13.60 15.19 18.78 18.61 18.40 18.43 18.41 * * * * * * * * * * * * * * * * * * * *
%vol 0.00 0.47 4.23 6.81 6.36 8.83 12.04 18.06 14.86 23.48 30.94 25.24 21.49 19.81 33.09 35.02 * * 33.69 * * * * * * * * * *
%pds 100.00 94.04 79.55 75.07 72.16 69.72 66.77 59.44 63.40 * * * * * * * * * * * * * * * * * * * *
%pds 0.00 5.31 15.11 16.63 20.13 19.84 19.48 19.21 19.35 * * * * * * * * * * * * * * * * * * * *
%pds 0.00 0.65 5.33 8.30 7.71 10.43 13.75 21.35 17.25 27.65 34.47 29.32 24.96 23.20 35.81 36.98 * * 36.18 * * * * * * * * * *
%pds 0.00 0.00 0.00 0.00 0.00 0.00 0.00 2.12 1.01 8.96 13.21 10.00 6.94 5.73 16.05 19.19 21.75 18.80 17.04 20.64 21.62 22.59 17.58 18.09 24.94 28.36 28.99 29.63 30.68
%pds 0.00 0.00 0.00 0.02 0.00 0.02 0.04 0.24 0.14 1.53 5.22 2.44 1.65 0.97 8.96 13.08 16.44 12.57 10.26 14.98 16.27 17.55 10.96 11.63 20.63 25.13 25.96 26.80 28.18
V04 V05 Viscosité à 40 °C Viscosité à 50 °C
mm2/s * * * * 9.29E-01 1.10E+00 1.37E+00 1.61E+00 1.48E+00 3.28E+00 1.00E+01 4.16E+00 2.79E+00 2.30E+00 3.90E+01 1.59E+02 4.88E+02 1.17E+02 5.81E+01 2.68E+02 4.72E+02 7.83E+02 7.08E+01 8.68E+01 1.54E+04 1.22E+06 3.64E+06 1.23E+07 1.27E+08
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-320001
mm2/s * * * * 8.28E-01 9.76E-01 1.22E+00 1.42E+00 1.31E+00 2.69E+00 7.42E+00 3.34E+00 2.33E+00 1.95E+00 2.51E+01 8.83E+01 2.52E+02 6.80E+01 3.59E+01 1.46E+02 2.44E+02 3.88E+02 4.31E+01 5.19E+01 5.75E+03 3.16E+05 8.62E+05 2.63E+06 2.25E+07
DOCUMENT No.: SA-JER-DS011-TRJR-
Coupe
Standard PI-36 Standard 36-40 Standard 40-50 Standard 50-60 Standard 60-70 Standard 70-80 Standard 80-90 Standard 90-100 Standard 100-110 Standard 110-120 Standard 120-130 Standard 130-140 Standard 140-150 Standard 150-160 Standard 160-170 Standard 170-180 Standard 180-190 Standard 190-200 Standard 200-210 Standard 210-220 Standard 220-230 Standard 230-240 Standard 240-250 Standard 250-260 Standard 260-270 Standard 270-280 Standard 280-290 Standard 290-300 Standard 300-310 Standard 310-320 Standard 320-330 Standard 330-340 Standard 340-350 Standard 350-360 Standard 360-370 Standard 370-380 Standard 380-390 Standard 390-400 Standard 400-410 Standard 410-420 Standard 420-430 Standard 430-440 Standard 440-450 Standard 450-460 Standard 460-480 Standard 480-500 Standard 500-520 Standard 520-540 Standard 540-560 Standard 560-580 Standard 580-600 Standard 600-PF Brut (recalculated)
V07 V10 V15 Viscosité à 70 °C Viscosité à 100 °C Viscosité à 150 °C
mm2/s * 2.14E-01 2.59E-01 3.23E-01 3.87E-01 4.50E-01 5.13E-01 5.76E-01 6.39E-01 7.01E-01 7.63E-01 8.26E-01 8.87E-01 9.49E-01 9.77E-01 1.01E+00 1.05E+00 1.08E+00 1.11E+00 1.16E+00 1.22E+00 1.29E+00 1.37E+00 1.47E+00 1.58E+00 1.71E+00 1.87E+00 2.06E+00 2.28E+00 2.54E+00 2.85E+00 3.23E+00 3.70E+00 4.22E+00 5.10E+00 6.15E+00 7.41E+00 8.89E+00 1.06E+01 1.27E+01 1.48E+01 1.73E+01 2.02E+01 2.36E+01 2.97E+01 3.93E+01 5.43E+01 8.36E+01 1.24E+02 2.01E+02 3.62E+02 9.28E+06 8.27E+00
mm2/s * 2.10E-01 2.38E-01 2.80E-01 3.22E-01 3.64E-01 4.06E-01 4.49E-01 4.91E-01 5.33E-01 5.75E-01 6.17E-01 6.59E-01 7.01E-01 7.43E-01 7.86E-01 8.28E-01 8.35E-01 8.50E-01 8.72E-01 9.01E-01 9.38E-01 9.82E-01 1.04E+00 1.10E+00 1.17E+00 1.26E+00 1.36E+00 1.47E+00 1.61E+00 1.77E+00 1.96E+00 2.18E+00 2.42E+00 2.82E+00 3.28E+00 3.81E+00 4.40E+00 5.06E+00 5.82E+00 6.46E+00 7.19E+00 8.04E+00 9.03E+00 1.08E+01 1.39E+01 1.85E+01 2.59E+01 3.54E+01 5.20E+01 8.28E+01 2.51E+05 4.36E+00
mm2/s * 2.04E-01 2.12E-01 2.32E-01 2.53E-01 2.75E-01 2.98E-01 3.22E-01 3.46E-01 3.70E-01 3.94E-01 4.19E-01 4.44E-01 4.69E-01 5.15E-01 5.58E-01 5.98E-01 5.92E-01 5.92E-01 5.96E-01 6.06E-01 6.20E-01 6.39E-01 6.62E-01 6.91E-01 7.25E-01 7.65E-01 8.12E-01 8.66E-01 9.29E-01 1.00E+00 1.08E+00 1.18E+00 1.28E+00 1.44E+00 1.62E+00 1.81E+00 2.01E+00 2.22E+00 2.46E+00 2.61E+00 2.78E+00 2.99E+00 3.24E+00 3.70E+00 4.57E+00 5.77E+00 7.38E+00 9.28E+00 1.22E+01 1.71E+01 4.82E+03 2.11E+00
REV: 02 Date: 05-APR-11
SUL Soufre
ASP7 Asphaltènes C7
CCR Carbone Conradson
H2N Hydrogène
NIC Nickel
VAN Vanadium
%pds 0.0000 0.0000 0.0000 0.0005 0.0014 0.0019 0.0025 0.0034 0.0045 0.0060 0.0088 0.0133 0.0267 0.0397 0.0567 0.0776 0.1012 0.1325 0.1675 0.2298 0.3309 0.5717 0.7692 0.9620 1.0635 1.0936 1.1246 1.3925 1.6793 1.9598 2.2133 2.2621 2.4378 2.5895 2.6358 2.6554 2.6752 2.6951 2.7152 2.7354 2.7636 2.7895 2.9110 3.0366 3.0870 3.1520 3.3445 3.5486 3.9101 4.0645 4.2249 5.7225 2.7851
%pds 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 24.83 6.15
%pds 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.01 0.01 0.01 0.02 0.02 0.05 0.44 0.89 1.25 1.92 2.88 4.17 5.87 32.81 8.55
wt % 17.61 16.84 16.60 16.30 16.04 15.82 15.65 15.66 15.51 15.37 15.22 15.08 14.94 14.75 14.63 14.54 14.49 14.39 14.27 14.16 14.04 13.92 13.79 13.67 13.57 13.49 13.40 13.26 13.11 12.97 12.82 12.69 12.57 12.46 12.38 12.30 12.24 12.19 12.14 12.10 12.06 12.03 11.92 11.89 11.90 11.69 11.66 11.54 11.35 11.19 11.05 9.61 12.69
mg/kg 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.4 2.5 3.7 5.2 7.4 71.2 18.1
mg/kg 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.4 2.2 3.9 6.9 11.6 233.3 58.4
TR Project No.: 02020 Page 22 of 48
MYLD Rendement masse Rendement masse Rendement ajusté cumulé %pds 3.278 0.154 0.404 0.458 0.546 0.665 0.796 0.900 1.002 1.089 1.161 1.216 1.256 1.288 1.308 1.317 1.317 1.316 1.323 1.337 1.358 1.387 1.415 1.440 1.463 1.480 1.497 1.512 1.524 1.534 1.541 1.546 1.544 1.532 1.507 1.471 1.431 1.393 1.360 1.329 1.304 1.281 1.268 1.255 2.512 2.729 2.899 2.810 4.223 1.802 1.748 24.774 100.000
%pds 3.278 3.432 3.836 4.294 4.840 5.505 6.301 7.201 8.203 9.292 10.453 11.669 12.925 14.213 15.521 16.838 18.155 19.471 20.794 22.131 23.489 24.876 26.291 27.731 29.194 30.674 32.171 33.683 35.207 36.741 38.282 39.828 41.372 42.904 44.411 45.882 47.313 48.706 50.066 51.395 52.699 53.980 55.248 56.503 59.015 61.744 64.643 67.453 71.676 73.478 75.226 100.000 100.000
%pds 3.278 3.355 3.634 4.065 4.567 5.172 5.903 6.751 7.702 8.747 9.872 11.061 12.297 13.569 14.867 16.179 17.496 18.813 20.132 21.462 22.810 24.182 25.583 27.011 28.462 29.934 31.422 32.927 34.445 35.974 37.511 39.055 40.600 42.138 43.657 45.146 46.597 48.009 49.386 50.730 52.047 53.339 54.614 55.875 57.759 60.379 63.193 66.048 69.564 72.577 74.352 87.613
VYLD Rendement volume
FPA Point d'éclair Abel
FPM Point d'éclair Pensky-Martens
FZP Point de cristallisation
N2T Azote total
N2B Azote basique
MWT Masse molaire
%vol 4.931 0.209 0.549 0.606 0.707 0.847 0.998 1.130 1.241 1.332 1.402 1.452 1.482 1.498 1.505 1.505 1.496 1.484 1.477 1.480 1.492 1.515 1.533 1.548 1.561 1.569 1.576 1.580 1.579 1.576 1.570 1.562 1.543 1.520 1.486 1.443 1.395 1.352 1.321 1.287 1.257 1.232 1.212 1.195 2.385 2.554 2.704 2.602 3.868 1.630 1.566 20.456 100.000
°C -62.9 -42.7 -39.1 -33.6 -27.9 -22.0 -15.8 -9.4 -2.8 3.9 10.8 17.8 24.9 32.1 39.3 46.6 54.0 61.4 66.8 71.8 76.8 81.9 86.9 91.9 96.9 101.9 106.8 111.7 116.6 121.5 126.3 131.1 135.9 140.6 145.3 150.0 154.7 159.3 163.9 168.5 173.1 177.6 182.1 186.6 193.4 202.3 211.3 220.3 229.2 238.3 247.3 301.6 -46.2
°C -59.9 -39.9 -36.3 -30.9 -25.2 -19.2 -13.0 -6.6 0.0 6.7 13.6 20.6 27.7 34.9 42.1 49.4 56.8 63.6 68.7 73.7 78.7 83.8 88.8 93.8 98.8 103.8 108.7 113.6 118.5 123.4 128.2 133.0 137.8 142.5 147.2 151.9 156.6 161.2 165.8 170.4 174.9 179.5 184.0 188.5 195.3 204.2 213.2 222.1 231.1 240.1 249.2 303.6 -42.6
°C * -125.3 -122.1 -117.5 -112.9 -108.3 -103.7 -99.2 -94.6 -90.0 -85.4 -80.9 -76.3 -71.7 -67.1 -62.5 -58.0 -52.9 -47.3 -42.1 -37.0 -32.2 -27.6 -23.3 -19.2 -15.3 -11.7 -8.4 -5.2 -2.2 0.7 3.6 6.3 8.8 9.9 10.4 10.9 11.4 11.9 12.4 12.9 13.4 13.9 14.4 15.1 16.1 * * * * * * *
%pds 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0001 0.0001 0.0002 0.0003 0.0005 0.0019 0.0023 0.0015 0.0010 0.0015 0.0024 0.0038 0.0061 0.0097 0.0155 0.0248 0.0300 0.0333 0.0369 0.0410 0.0455 0.0505 0.0616 0.0792 0.0861 0.0964 0.1243 0.0867 0.1210 0.1441 0.1836 0.2100 0.2403 0.6656 0.2022
%pds 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0004 0.0009 0.0015 0.0021 0.0026 0.0032 0.0037 0.0043 0.0048 0.0061 0.0077 0.0096 0.0131 0.0150 0.0167 0.0180 0.0193 0.0206 0.0219 0.0238 0.0234 0.0283 0.0333 0.0422 0.0621 0.0736 0.1410 0.0444
61.3 71.0 74.4 79.3 84.1 88.9 93.7 98.7 103.8 109.1 114.5 120.0 125.7 131.3 137.3 143.5 150.0 156.5 163.2 170.0 177.1 184.4 191.8 199.5 207.4 215.6 224.1 232.5 241.2 250.1 259.2 268.3 278.0 288.0 298.5 309.3 320.6 332.5 344.7 357.4 370.7 384.6 397.5 412.4 436.6 465.6 501.0 536.8 573.3 612.1 653.9 1005.9 249.1
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-320001
DOCUMENT No.: SA-JER-DS011-TRJR-
Coupe
Standard PI-15 Standard 15-75 Standard 15-145 Standard 15-190 Standard 75-145 Standard 75-190 Standard 145-190 Standard 190-230 Standard 145-230 Standard 230-340 Standard 340-375 Standard 230-375 Standard 145-375 Standard 145-340 Standard 375-460 Standard 460-500 Standard 500-560 Standard 375-560 Standard 375-500 Standard 500-520 Standard 520-540 Standard 540-560 Standard 375-520 Standard 375-540 Standard 375-PF Standard 500-PF Standard 520-PF Standard 540-PF Standard 560-PF
V07 V10 V15 Viscosité à 70 °C Viscosité à 100 °C Viscosité à 150 °C
mm2/s * * * * 6.72E-01 7.90E-01 9.84E-01 1.14E+00 1.05E+00 1.92E+00 4.49E+00 2.31E+00 1.71E+00 1.48E+00 1.23E+01 3.42E+01 8.60E+01 2.83E+01 1.65E+01 5.43E+01 8.36E+01 1.24E+02 1.92E+01 2.25E+01 1.15E+03 3.41E+04 7.99E+04 2.06E+05 1.27E+06
mm2/s * * * * 5.13E-01 6.02E-01 7.50E-01 8.64E-01 8.01E-01 1.29E+00 2.55E+00 1.50E+00 1.18E+00 1.05E+00 5.61E+00 1.23E+01 2.66E+01 1.09E+01 7.03E+00 1.85E+01 2.59E+01 3.54E+01 7.98E+00 9.06E+00 1.98E+02 2.89E+03 5.67E+03 1.20E+04 5.14E+04
mm2/s * * * * 3.59E-01 4.18E-01 5.21E-01 5.96E-01 5.55E-01 7.84E-01 1.33E+00 8.85E-01 7.42E-01 6.74E-01 2.37E+00 4.12E+00 7.52E+00 3.88E+00 2.78E+00 5.77E+00 7.38E+00 9.28E+00 3.07E+00 3.38E+00 3.05E+01 2.03E+02 3.27E+02 5.57E+02 1.56E+03
REV: 02 Date: 05-APR-11
SUL Soufre
ASP7 Asphaltènes C7
CCR Carbone Conradson
H2N Hydrogène
NIC Nickel
VAN Vanadium
%pds 0.0000 0.0005 0.0057 0.0264 0.0084 0.0337 0.0644 0.2161 0.1367 1.3895 2.5677 1.6789 1.1535 0.8802 2.7775 3.1208 3.6428 3.1693 2.8859 3.3445 3.5486 3.9101 2.9541 3.0290 4.3854 5.0360 5.1747 5.3151 5.5246
%pds 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 11.22 16.08 17.40 18.90 21.72
%pds 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.01 0.67 2.13 0.94 0.22 1.25 1.92 2.88 0.37 0.57 15.60 22.27 23.99 25.89 29.33
wt % 18.31 16.57 15.84 15.46 15.38 15.06 14.64 14.22 14.44 13.33 12.45 13.13 13.61 13.81 12.09 11.79 11.50 11.82 12.00 11.66 11.54 11.35 11.95 11.90 10.77 10.29 10.18 10.06 9.83
mg/kg 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 2.4 0.9 0.0 0.4 2.5 3.7 0.1 0.4 33.0 47.3 51.2 55.4 63.1
mg/kg 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 0.0 2.4 0.9 0.0 0.4 2.2 3.9 0.1 0.3 106.4 152.5 165.0 179.1 205.2
TR Project No.: 02020 Page 23 of 48
MYLD Rendement masse Rendement masse Rendement ajusté cumulé %pds 1.541 3.632 10.756 16.614 7.124 12.982 5.858 5.334 11.192 16.339 5.319 21.658 32.850 27.531 11.356 5.241 9.932 26.529 16.597 2.899 2.810 4.223 19.496 22.306 54.853 38.256 35.357 32.547 28.324
%pds 1.541 5.173 12.297 18.155 12.297 18.155 18.155 23.489 23.489 39.828 45.147 45.147 45.147 39.828 56.503 61.744 71.676 71.676 61.744 64.643 67.453 71.676 64.643 67.453 100.000 100.000 100.000 100.000 100.000
%pds
VYLD Rendement volume
FPA Point d'éclair Abel
FPM Point d'éclair Pensky-Martens
FZP Point de cristallisation
N2T Azote total
N2B Azote basique
MWT Masse molaire
%vol 2.412 4.954 13.699 20.478 8.745 15.524 6.779 5.933 12.712 17.169 5.274 22.443 35.155 29.881 10.969 4.939 9.174 25.082 15.908 2.704 2.602 3.868 18.612 21.214 48.734 32.826 30.122 27.520 23.652
°C -66.1 -45.6 -39.2 -36.5 -6.6 -1.4 37.2 67.8 44.5 98.6 141.2 102.2 58.7 56.3 165.9 197.6 220.4 181.0 171.9 211.3 220.3 229.2 174.8 177.4 198.4 252.3 261.0 269.8 285.7
°C -63.2 -42.7 -36.1 -33.3 -3.7 1.6 40.1 69.7 47.4 100.6 143.1 104.2 61.9 59.5 167.8 199.5 222.3 183.0 173.8 213.2 222.1 231.1 176.8 179.4 200.5 254.4 263.1 271.9 287.7
°C * -122.4 -99.4 -85.4 -90.0 -77.9 -65.7 -44.4 -54.6 -11.4 8.6 -5.9 -18.3 -25.3 12.4 15.6 * * 13.5 * * * * * * * * * *
%pds 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0001 0.0000 0.0029 0.0248 0.0082 0.0054 0.0017 0.0595 0.1047 0.1542 0.1039 0.0738 0.1210 0.1441 0.1836 0.0808 0.0888 0.3654 0.4920 0.5224 0.5550 0.6104
%pds 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0013 0.0054 0.0023 0.0015 0.0008 0.0160 0.0236 0.0356 0.0249 0.0184 0.0283 0.0333 0.0422 0.0199 0.0216 0.0801 0.1068 0.1133 0.1202 0.1318
52.4 76.2 94.4 106.3 107.5 119.6 138.5 166.4 150.6 222.7 290.6 236.2 197.9 186.4 357.4 451.2 540.1 429.4 382.5 501.0 536.8 573.3 396.5 410.0 596.1 786.6 825.2 865.3 936.4
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-320001
DOCUMENT No.: SA-JER-DS011-TRJR-
REV: 02 Date: 05-APR-11
APPENDIX 2
TR Project No.: 02020 Page 25 of 48
JERP CDU / VDU
COMPOSITION OF THE CUT PI-145 IN CRUDE SELECTED PURE COMPONENTS CUT 15-145
SELECTED PURE COMPONENTS CUT PI-15
Yield on CRUDE (wt %)
10,91
Components
% wt
Ethane Propane Isobutane N-butane Neopentane Isopentane N-pentane Cyclo-pentane 2,3-diméthyl-butane 2-méthyl-pentane 3-méthyl-pentane N-hexane Méthyl-cyclo-pentane 2,4-diméthyl-pentane Benzène Cyclo-hexane 2-méthyl-hexane 2,3-diméthyl-pentane 3-méthyl-hexane 3-éthyl-pentane 1-trans-2-diméthyl-cyclo-pentane N-heptane 1-cis-2-diméthyl-cyclo-pentane Ethyl-cyclo-pentane 2,4-diméthyl-hexane 1-trans-2-cis-3-triméthyl-cyclo-pentane Toluène 2-méthyl-heptane 4-méthyl-heptane 3-méthyl-heptane (Note 4) 1-méthyl-trans-2-éthyl-cyclo-pentane 1-trans-2-diméthyl-cyclo-hexane N-octane (Note 5) Ethyl-cyclo-hexane 2,6-diméthyl-heptane 1,1,3-triméthyl-cyclo-hexane Ethyl-benzène 1,3,5-triméthyl - cyclo - hexane (Note 1) Métaxylène + paraxylène (Note 2) 2,3-diméthyl-heptane 2-méthyl-octane 3-méthyl-octane Orthoxylène 1,2,3,5-tetramethyl - cyclo - hexane (Note 3) N-nonane 2-5 diméthyl-octane
0,00 0,01 0,09 1,61 0,00 5,30 10,13 0,52 0,77 4,41 3,72 10,77 1,81 0,37 0,29 1,18 2,64 1,11 3,59 0,36 1,68 10,36 2,43 0,59 2,28 1,40 1,50 3,18 1,01 2,62 1,05 1,30 8,36 1,09 1,96 0,64 0,83 0,57 1,39 0,71 1,49 1,36 0,64 0,68 1,95 0,24 100,00
SELECTED PURE COMPONENTS
CUT PI-145
Yield on CRUDE (wt %)
1,40
Components
% wt
Ethane Propane Isobutane N-butane Neopentane Isopentane N-pentane
2,10 31,15 13,37 49,81 0,08 2,57 0,92
100,00
Yield on CRUDE (wt %)
12,31
Components
% wt
Ethane Propane Isobutane N-butane Neopentane Isopentane N-pentane Cyclo-pentane 2,3-diméthyl-butane 2-méthyl-pentane 3-méthyl-pentane N-hexane Méthyl-cyclo-pentane 2,4-diméthyl-pentane Benzène Cyclo-hexane 2-méthyl-hexane 2,3-diméthyl-pentane 3-méthyl-hexane 3-éthyl-pentane 1-trans-2-diméthyl-cyclo-pentane N-heptane 1-cis-2-diméthyl-cyclo-pentane Ethyl-cyclo-pentane 2,4-diméthyl-hexane 1-trans-2-cis-3-triméthyl-cyclo-pentane Toluène 2-méthyl-heptane 4-méthyl-heptane 3-méthyl-heptane (Note 4) 1-méthyl-trans-2-éthyl-cyclo-pentane 1-trans-2-diméthyl-cyclo-hexane N-octane (Note 5) Ethyl-cyclo-hexane 2,6-diméthyl-heptane 1,1,3-triméthyl-cyclo-hexane Ethyl-benzène 1,3,5-triméthyl - cyclo - hexane (Note 1) Métaxylène + paraxylène (Note 2) 2,3-diméthyl-heptane 2-méthyl-octane 3-méthyl-octane Orthoxylène 1,2,3,5-tetramethyl - cyclo - hexane (Note 3) N-nonane 2-5 diméthyl-octane
0,24 3,55 1,60 7,10 0,01 4,99 9,08 0,46 0,68 3,91 3,29 9,55 1,61 0,33 0,26 1,04 2,34 0,98 3,19 0,32 1,49 9,18 2,15 0,53 2,02 1,24 1,33 2,82 0,89 2,32 0,93 1,15 7,41 0,96 1,74 0,57 0,73 0,51 1,23 0,63 1,32 1,20 0,57 0,61 1,73 0,21 100,00
% wt
0,029 0,438 0,197 0,874 0,001 0,614 1,118 0,057 0,083 0,481 0,405 1,175 0,198 0,041 0,032 0,129 0,288 0,121 0,392 0,040 0,183 1,130 0,265 0,065 0,248 0,153 0,164 0,347 0,110 0,286 0,114 0,142 0,912 0,119 0,214 0,070 0,090 0,063 0,152 0,078 0,163 0,148 0,070 0,075 0,213 0,026 12,31
This document is property of TR Group. Reproduction thereof without prior written permission is strictly forbidden.
SA-JER-DS011-TRJR-320001
DOCUMENT No.: SA-JER-DS011-TRJR-320001
REV: 02 Date: 05-APR-11
TR Project No.: 02020 Page 36 of 48
Expected quality of SR NAPHTHA
Units
Calculated properties
Lab
Method
TBP Cut range
°C
IP-145
IP - 145
ASTM D2892
Yield on Crude
% wt
12.30
12.31
-
% vol
16.16
16.08
0.675
0.679
Characteristics
Specific Gravity (15°C) ASTM D86 Distillation (%vol), IBP 5% 10% 30% 50% 70% 90% 95% FBP
ASTM D2598 / D1298
°C °C °C °C °C °C °C °C °C
-14 13 25 52 86 106 127 136 148
Total Sulfur
ppm wt
62
52
ASTM D2622 / D2784
Total Nitrogen
ppm wt
232
(A) (B) (D) (F) (G) (H) (K) (O)
F
1
3
0
-15
0,4
15,0
0,48
>-14
>1
>232
(A) (B) (D) (F) (G) (H) (K) (O)
F
1
3
0
-35
0,9
7,6
0,294
30-177
>1
290
(A) (B) (C) (D) (E) (F) (G) (H) (K) (O)
F
2
3
0
20
0,4
15,0
0,0877
>150
>1
>232
(A) (B) (D) (E) (F) (G) (H) (K) (O)
F
1
3
0
-67
0,9
7,6
0,3211
30-177
>1
290
(A) (B) (C) (D) (E) (F) (G) (H) (K) (O)
F
1
3
0
-35
0,9
7,6
0,3507
30-177
>1
290
(A) (B) (C) (D) (E) (F) (G) (H) (K) (O)
F
1
4
0
-82
0,9
7,6
1,368
30-177
>1
290
(A) (B) (C) (D) (E) (F) (G) (H) (K) (O)
T (11)
4 (10)
-
-
NA
NA
NA
0,02341
≈100
>1
NA
(A) (O)
F
2
2
0
38
0,7
6,0
0,03586
145-301
>1
210
(A) (B) (D) (E) (F) (G) (H) (K) (O)
C
0
2
0
82
0,5
6,5
0,0238
230-300
>1
>250
(A) (B) (D) (E) (F) (G) (H) (K) (O)
C
0
2
0
112
0,5
6,5
0,02347
300-360
>1
>250
(A) (B) (D) (E) (F) (G) (H) (K) (O)
C
4 (10)
2
0
127
0,5
6,5
0,03759
379-550
>1
210270
(A) (B) (D) (F) (H) (O)
F
4 (10)
3
1
-90
4,8
32,5
133
1
270
(A) (B) (D) (F) (H) (O)
F
4 (10)
4
0
-60
3.8-6.5
13-17
>300
-162
>1
372
(A) (B) (D) (F) (H) (O)
NA
N/A
N/A
N/A
NA
NA
NA
0,02341
≈100
>1
NA
(O) (P)
F
1
4
0
-104
1,4
11
8,1
-42
>1
NA
(A) (D) (F) (H)
T / CR (11)
4 (10)
-
-
NA
NA
NA
0,02341
≈100
>1
NA
(M) (N) (K) (O)
S
4 (10)
0
0
NA
NA
NA
0,02341
≈100
>1
NA
(M) (N) (K) (O)
S
NA
NA
NA
NA
NA
NA
>50
1
-
(I) (F) (H) (O)
C
1
2
0
>58
(5)
(5)
1
>450
((B)) ((D)) ((G)) ((K)) ((P)) ((5))
S
2
0
N/A
Non combustible
NA
NA
≈0
-
>1
None
(A) (B) (D) (G) (P) (J) (5)
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 20.
FIRE HAZARD ENVELOPE LAYOUT Document Number
Description
SA-JER-DS011-TRJR-345801
FIRE HAZARD ENVELOPE LAYOUT
Rev. 03
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 21.
FIRE & GAS DETECTION LAYOUT Document Number
Description
SA-JER-DS011-TRJR-345803
FIRE & GAS DETECTION LAYOUT
Rev. 04
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
ORIGINAL SIGNED IN PROJECT FILE
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 22.
FIRE PROTECTION LAYOUT Document Number
Description
SA-JER-DS011-TRJR-345802
FIRE PROTECTION LAYOUT
Rev. 05
ORIGINAL SIGNED IN PROJECT FILE
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 23.
FIRE WATER DEMAND Document Number
Description
SA-JER-DS011-TRJR-675801
FIRE WATER DEMAND
Rev. 01
DOCUMENT No.:
SA-JER-DS011-TRJR-675801
P.O TR Project No.: 02020
FIRE WATER DEMAND UNIT 011-CRUDE DISTILLATION UNIT TRAIN 1 ORIGINAL SIGNED IN PROJECT FILE
REVISION CONTROL REV. 00 01
DATE 30/06/2010 25/05/2011
DESCRIPTION IFD Issue for design AFC Approved for construction
DISCIPLINE CODE
DOCUMENT TYPE
UNIT
137
LIS
011
SYSTEM
Document class: 2 PREPARED BY Isaac Diaz
/
Angel Rubio
CHECKED BY
APPROVED BY
Luis Beltran
Juan A. Lechuga
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801
TR Jubail
CRUDE DISTILLATION UNIT TRAIN 1 FIRE WATER DEMAND AFC
1. INTRODUCTION Scope of this document is to evaluate and to estimate the better approach in order to identify and design the fire fighting protection system. The approach is based on the evaluation for any equipment of the fluid handled, the operating conditions, and the context they are located. 2. HAZARDOUS SUBSTANCES HANDLED
CRUDE DISTILLATION UNIT TRAIN 1 handle different hazardous substances. In order to ensure proper application of the fire protection to those Units, the fist step of the study is to identify and classify the Hazardous Substances. With regard to those substances that can burn in presence of air and giving an ignition, the classification in terms of liquid follows the COMPANY standard JERES-B-017 “Fire Water System design”; the two categories are: • flammable • combustible. A further division has been done to evaluate the operating condition where the equipment handles the hazardous substances. Following the criteria explained in the standard JERES-B-017 the equipment have been protected with fixed spray system, double monitor, or single monitor, see drawing SA-JER-DS-011-TRJR-345802. 01 3. POOL FIRE SCENARIOS In order to a convenient active fire fighting protection of the Plant the most important step is to define the different fire scenarios inside a RISK AREA (FIRE FIGHTING ZONE). The boundaries of a risk area “fire fighting zone” shall be determined by the outermost equipment, vessel, and any included pipeways, containing process flammable / combustible liquid or combustible gases. The number and the dimension of Risk Areas “fire fighting zones”, inside a single process area (normally coincident with a single process unit) will be defined by the Fire fighting study based on a maximum water flow rate of 1200 m3/h for each risk area “fire fighting zone”. For fire scenario has been considered the liquid pool fire that can occur in a maximum area of four catch basin (1200 m2) in case of liquid pool fire of all equipment inside this considered area (four catch basin) basin). Inside of the process facilities (process unit) have been evaluated all different pool fire scenarios (see the attachment A1) The fire scenario comprise, in additional to the equipment inside the considered area (four catch basin), also the equipment adjacent that are exposed to a radiation greater than 12.5 kW/m2 from the liquid pool fire
In the fire water demand is shown the different pool fire scenarios, and the adjacent additional area (see the attachment A1) In the same attachments are shows the equipments inside the relevant pool fire and adjacent equipments exposed to a radiation greater than 12,5kW from the liquid pool fire. The fire protection system and the relevant water quantity for those fire exposure/involved equipment are based in the JERES-B-017. The fire water demand calculated for each scenario is shown in this document
NOTES.Revised document follows (*)
(**)
·
01
Exposed equipment surfaces should be considered as follows: o For adjacent pumps and compressors exposed to radiation greater than 12.5 kW/m2, from grade to a height of 7.5m, use 50% of the surface area of the equipment and a water spray density of 0.34 L/m2s. o For adjacent vessels and columns exposed to radiation greater than 12.5 kW/m2, from grade to a height of 7.5m, use 50% of the total vessel/column (including exchangers) surface area and a water spray density of 0.10 L/m2/sec. o For these radiant heat exposure calculations calculations, any part of adjacent equipment more than 7 7.5m 5m above grade can be ignored ignored. Unless required elsewhere in this Standar or because it is recommended by Risk Assessment studies, monitor protection is required at least up to 20 m from grade or elevated structures sustaining the spread liquid.
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 01
02
Equipment involved on fire:
FIXED SPRAY SYSTEM
011-C-0003
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
X
011 C 0007 011-C-0007
X
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
TL. 11500
0083
15 m
0076
21 m
-
-
TL 10600 TL.
0076
25 m
-
-
-
-
ELEVATION
011-S-0002
X
TOS. 100300
0083
21 m
0051
27 m
-
-
011-S-0001
X
TOS. 100300
0053
28 m
0051
28 m
-
-
011-G-0018 A/B
X
BP. 100300
0052
22,6 n
0053
23 m
-
-
011-K-0001
X
BP. 100300
0077
15 m
-
-
-
-
011-D-0017
X
TL. 114000
0051
24m
011-D-0009
X
TL. 114000
0051
24m
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
Equipment fire exposed:
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
011-G-0015B
X
BP. 10300
0052
011-D-0008
X
CL. 108450
0051
15,75 m
-
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
0053
18m
0053
17,5 m
-
-
-
-
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
See notes (*)
MONITORS WORKED IN SCENARIO 0051
0052
0053
0054
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2
L/min/m2
0076
0077
0083
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
DESCRIPCION
m
m
m
m2
LATERAL SURFACE
L/min
HIDRAULIC GRADIENT(3) 10% L/min
L/min
m3/h
15,00
300,00
30,00
330,00
19,80
TOTAL SYSTEM
300,00
330,00
19,80
330,00
19,80
TOTAL REQUIRED
330,00
19,80
13.440,00
806,40
TOTAL REQUIRED
13.440,00
806,40
330,00 13.440,00
19,80 806,40
13.770,00
826,20
TOTAL FLOW
SYSTEM Nº 1 Water courtain Compressors
20,00
FIREWATER DEMANDS REQUIRED DELUGE SYSTEMS
REQUIRED MONITORS
SYSTEM Nº 1
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
7
FIREWATER DEMANDS UNIT FLOW
1.920,00
2 7
TOTAL TO BE INSTALLED
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 02
Equipment involved on fire: 01
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-C-0003
-
X
-
TL. 111500
0083
15 m
0076
21 m
-
-
011-C-0002
-
X
-
TL. 111500
0054
16 m
0076
15,6 m
-
-
011-G-0017 A/B
x
-
-
-
-
-
-
-
-
011-D-0017 011-D-0009 Equipment fire exposed: 01
FIXED SPRAY SYSTEM
-
BP, 100300
-
-
X
TL. 114000
0051
24m
X
TL. 114000
0051
24m
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
-
-
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-C-0007
-
-
X
TL. 106000
0076
25 m
-
-
-
-
011-G-0018 B
-
X
-
BP. 100300
0052
22,6 n
0053
23 m
-
-
011-K-0001
-
-
X
BP, 100300
0077
15 m
-
-
-
-
011-E-0022
-
X
-
CL. 106940
0075
17 m
0074
19,8 m
-
-
0053
0054
0074
0076
0077
0075
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2
L/min/m2
15,00
MONITORS WORKED IN SCENARIO
0083
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
DESCRIPCION
m
m
m
m2
LATERAL SURFACE
L/min
HIDRAULIC GRADIENT(3) 10% L/min
L/min
m3/h
300,00
30,00
330,00
19,80
330,00
19,80
TOTAL FLOW
SYSTEM Nº 1 Water courtain Compressors
20,00
TOTAL SYSTEM
300,00
SYSTEM Nº 3 011-G-0017A 011-G-0017B
20,40 20,40
TOTAL SYSTEM
543,45 543,45
54,35 54,35
543,45
597,80 597,80 1.195,59
71,74
1.195,59 330,00
71,74 19,80
1.525,59
91,54
TOTAL SYSTEM SYSTEM Nº 3 REQUIRED DELUGE SYSTEM Nº 1 SYSTEMS
REQUIRED MONITORS
MONITOR
QUANT:
7
FIREWATER DEMANDS UNIT FLOW
1.920,00
TOTAL REQUIRED DELUGE SYSTEMS MONITORS
QUANT: QUANT:
2 7
TOTAL TO BE INSTALLED
13.440,00
806,40
13.440,00
806,40
1.525,59 13.440,00
91,54 806,40
14.965,59
897,94
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 03
Equipment involved on fire:
01
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
-
X
-
TL. 115000
0054
16 m
0076
15,6 m
-
-
011-C-0002 011-C-0004
-
X
-
TL. 107000
0074
27m
0075
23,5m ,
011-C-0005
-
-
X
TL. 123700
0055
15,5m
0074
24 m
011-C-0006
-
X
-
TL. 109000
0055
15,5m
0074
25m
011-E-0022
-
X
-
CL. 106900
0075
17 m
0074
19,8 m
011-G-0014A
X
-
-
BP. 100300
-
-
-
-
011-G-0017A/B
See note (**) -
-
X
-
-
BP. 100300
-
-
-
-
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-C-0003
-
X
-
TL. 115000
0083
15 m
0076
21 m
-
-
011-G-0007A/B
-
X
-
BP. 100300
0081
16 m
0075
19 m
011-G-0009A/B
-
X
-
BP. 100300
0055
15m
0074
17m
011-G-0011A
-
X
-
BP. 100300
0054
25,5m
0073
27 m
011-G-0013A/B
-
X
-
BP. 100300
0074
24m
0054
27m
011-G-0014B
X
-
-
BP. 100300
-
-
-
-
0076
0054
0074
0073
0081
0055
LATERAL SURFACE
Equipment fire exposed:
01
See note (*)
MONITORS WORKED IN SCENARIO
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
DESCRIPCION
m
m
m
m2
0083
0075
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2
L/min/m2
L/min
HIDRAULIC GRADIENT(3) 10% L/min
L/min
m3/h
20,40
342,73 342,73
34,27 34,27
377,00 377,00
22,62
TOTAL SYSTEM
685,45
754,00
45,24
20,40 20,40
543,45 543,45
TOTAL SYSTEM
543,45
TOTAL FLOW
SYSTEM Nº 2 011-G-00014A 011-G-00014B
SYSTEM Nº 3 011-G-0017A 011-G-0017B
54,35 54,35
597,80 597,80 1.195,59
71,74
754,00 1.195,59
45,24 71,74
TOTAL REQUIRED
1.949,59
116,98
15.360,00
921,60
TOTAL REQUIRED
15.360,00
921,60
1.949,59 15.360,00
116,98 921,60
17.309,59
1.038,58
FIREWATER DEMANDS SYSTEM Nº 2 REQUIRED DELUGE SYSTEM Nº 3 SYSTEMS
REQUIRED MONITORS
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
8
FIREWATER DEMANDS UNIT FLOW
1.920,00
2 8
TOTAL TO BE INSTALLED
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 04 01
Equipment involved on fire:
01
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT -
011-C-0002
-
X
-
TL. 111500
0054
16 m
0076
15,6 m
-
011-C-0004 011 C 0004
-
X
-
TL. 107000
0074
27m
0075
23,5m
-
-
011-C-0005
-
-
X
TL. 1023700
0055
15,5m
0074
24 m
-
-
011-C-0006
-
X
-
TL. 109000
0055
15,5m
0074
25m
-
-
011-D-0005
-
x
-
TL. 109400
0073
24m
0074
15m
-
-
011-D-0004
-
x
-
TL. 118550
0073
17m
0074
15m
011-E-0022
-
X
-
CL. 106940
0075
17 m
0074
19,8 m
-
-
011-G-0007A/B
-
X
-
BP. 100300
0081
16 m
0075
19 m
011-G-0009A/B
-
X
-
BP. 100300
0055
15m
0074
17m
011-G-0011A
-
X
-
BP. 100300
0054
25,5m
0073
27 m
011-G-0012A/B
-
X
-
BP. 100300
0054
27m
0073
22m
0055
15m
011-G-0013A/B
-
X
-
BP. 100300
0074
24m
0074
24m
011-G-0014A/B
X
-
BP. 100300
-
-
-
-
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
Equipment fire exposed:
01
FIXED SPRAY SYSTEM
ELEVATION
011-E-0021
-
X
-
CL. 116150
0073
17 m
0074
15 m
011-G-0005A 011 G 0005A
-
X
-
BP. 100300
0055
18 m
0073
18 m
011-G-0010A
-
X
-
BP. 100300
0055
20 m
0073
19 m
0054
0055
0074
0076
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2
L/min/m2
20,40
See note (**)
See note (*)
MONITORS WORKED IN SCENARIO 0075
0073
0081
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
DESCRIPCION
m
m
m
m2
LATERAL SURFACE
L/min
HIDRAULIC GRADIENT(3) 10% L/min
L/min
m3/h
342,73 342,73
34,27 34,27
377,00 377,00
22,62 22,62
754,00
45,24
754,00
45,24
TOTAL REQUIRED
754,00
45,24
13.440,00
806,40
TOTAL REQUIRED
13.440,00
806,40
754,00 13.440,00
45,24 806,40
14.194,00
851,64
TOTAL FLOW
SYSTEM Nº 2 011-G-00014A 011-G-00014B
TOTAL SYSTEM
685,45
TOTAL SYSTEM FIREWATER DEMANDS REQUIRED DELUGE SYSTEMS
REQUIRED MONITORS
SYSTEM Nº 2
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
7
FIREWATER DEMANDS UNIT FLOW
1.920,00
1 7
TOTAL TO BE INSTALLED
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 05
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-D-0004
-
x
-
CL. 118500
0073
17 m
0074
15m
-
-
011-D-0005
-
x
-
CL. 109400
0073
24 m
0074
15m
-
-
011-E-0021
-
X
-
CL. 116150
0073
17 m
0074
15 m
-
-
011-G-0005A/B
-
X
-
BP. 100300
0055
18 m
0073
18 m
-
-
011-G-0007A/B
-
X
-
BP. 100300
0081
16 m
0075
19 m
-
-
011-G-0009A/B
-
X
-
BP. 100300
0055
15m
0074
17m
-
-
011-G-0010A/B
-
X
-
BP. 100300
0055
20 m
0073
19 m
-
-
011-G-0011A/B
-
X
-
BP. 100300
0054
25,5m
0073
27 m
-
-
011-G-0012A/B
-
X
-
BP. 100300
0054
27m
0073
22m
0055
15m
011-G-0013A/B
-
X
-
BP. 100300
0074
24m
0054
27m
-
-
-
BP. 100300
-
-
-
-
-
-
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-C-0004
-
X
-
TL. 107000
0074
27m
0075
23,5m
-
-
011-C-0005
-
-
X
TL. 123700
0055
15,5m
0074
24 m
-
-
See note (*)
011-C-0006
-
X
-
TL. 109000
0055
15,5m
0074
25m
-
-
See note (*)
011-E-0022
-
X
-
CL. 106900
0075
17 m
0074
19,8 m
-
-
011-G-0008A/B
X
-
-
BP. 100300
-
-
-
-
-
-
011 G 0014B 011-G-0014B
X
-
-
BP. 100300
0074
24m
0076
22m
-
-
0054
0055
0073
0074
0075
0081
LATERAL SURFACE
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2
L/min/m2
Equipment involved on fire:
01
011-G-0014A
X Equipment fire exposed:
01
MONITORS WORKED IN SCENARIO
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
DESCRIPCION
m
m
m
m2
L/min
HIDRAULIC GRADIENT (3) 10% L/min
L/min
m3/h
20,40
342,73 342,73
34,27 34,27
377,00 377,00
22,62 22,62
TOTAL SYSTEM
685,45
754,00
45,24
20,40 6,00 6,00 ,
489,60 943,23 943,23 ,
TOTAL FLOW
SYSTEM Nº 2 011-G-00014A 011-G-00014B
SYSTEM Nº4
011-G-0008 A/B (2 Units) 011-D-0001 011-D-0002
3,00 26,00 26,00 ,
4,00 3,60 3,60 ,
10,18 10,18
147,03 147,03 ,
24,00 157,21 157,21 ,
48,96 94,32 94,32 ,
TOTAL SYSTEM
538,56 1.037,55 1.037,55 ,
2.613,67
156,82
754,00 2.613,67
45,24 156,82
TOTAL REQUIRED
3.367,67
202,06
11.520,00
691,20
TOTAL REQUIRED
11.520,00
691,20
3.367,67 11.520,00
202,06 691,20
14.887,67
893,26
FIREWATER DEMANDS SYSTEM Nº 2 REQUIRED DELUGE SYSTEM Nº4 SYSTEMS
REQUIRED MONITORS
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
6
FIREWATER DEMANDS UNIT FLOW
1.920,00
2 6
TOTAL TO BE INSTALLED
01
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 06
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-D-0004
-
X
-
CL. 118550
0073
24m
0074
15m
-
-
011-D-0005
-
X
-
CL. 109400
0073
24m
0074
15m
-
-
011 E 0021 011-E-0021
-
X
-
CL 116150 CL.
0073
17 m
0074
15 m
-
-
011-G-0005A/B
-
X
-
BP. 100300
0055
18 m
0073
18 m
-
-
011-G-0008A/B
X
-
-
BP. 100300
-
-
-
-
-
-
011-G-0010A/B
-
X
-
BP. 100300
0055
20 m
0073
19 m
-
-
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-G-0011B
-
X
-
BP. 100300
0054
25,5m
0073
27 m
-
-
011-G-0012A/B
-
X
-
BP. 100300
0054
27m
0073
22m
0055
15m
011-D-0001
X
-
-
CL. 105330
-
-
-
-
011-G-0007A/B
-
X
-
BP. 100300
0081
16 m
0075
19 m
-
-
0054
0055
0073
0074
0075
0081
Equipment involved on fire:
Equipment fire exposed:
MONITORS WORKED IN SCENARIO
DELUGE VALVE STATION Nº
L/min
HIDRAULIC GRADIENT(3) 10% L/min
L/min
m3/h
20,40
342,73 342,73
34,27 34,27
377,00 377,00
22,62 22,62
TOTAL SYSTEM
685,45
754,00
45,24
6,00 6,00 20,40
943,23 943,23 489,60
1037,55 1037,55 538,56
62,25 62,25
TOTAL SYSTEM
1.886,46
2.613,67
156,82
754,00 2.613,67
45,24 156,82
TOTAL REQUIRED
3.367,67
202,06
11.520,00
691,20
TOTAL REQUIRED
11.520,00
691,20
3.367,67 11.520,00
202,06 691,20
14.887,67
893,26
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
TOTAL SURFACE
FLOW RATE(1)
FLOW
DESCRIPCION
m
m
m
m2
m2
m2
L/min/m2
TOTAL FLOW
SYSTEM Nº 2 011-G-00014A 011-G-00014B
SYSTEM Nº 4 011-D-0001 011-D-0002 011-G-0008 A/B (2 Units)
26,00 26,00 3,00
3,60 3,60
(upper half) 10,18 10,18
4,00
(upper half) 147,03 147,03
(upper half) 157,21 157,21 24,00
94,32 94,32 48,96
TOTAL SYSTEM FIREWATER DEMANDS SYSTEM Nº 2 REQUIRED DELUGE SYSTEM Nº 4 SYSTEMS
REQUIRED MONITORS
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
6
FIREWATER DEMANDS UNIT FLOW
1.920,00
2 6
TOTAL TO BE INSTALLED
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 07
Equipment involved on fire:
01
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
X
-
-
CL. 105330
-
-
-
-
011-D-0001
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-D-0002
X
-
-
CL. 105330
-
-
-
-
011-G-0008A/B
X
-
-
BP. 100300
-
-
-
-
-
-
011-G-0025
-
-
x
BP. 100300
0073
15,5m
-
-
-
-
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-G-0010A/B
-
X
-
BP. 100300
0055
20 m
0073
19 m
-
-
011-G-0005/B
-
X
-
BP. 100300
0055
18 m
0073
18 m
-
-
011-A-0005
-
x
-
EL. 119000
0068
17m
0069
15m
0085
17m
011-G-0002A
-
x
-
BP. 100300
0082
23,3 m
0084
21m
-
-
0082
0084
Equipment fire exposed: 01
PROTECTED BY MONITOR MLZ-
-
-
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
-
-
See note (*)
MONITORS WORKED IN SCENARIO 0055
0068
0069
0073
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2
L/min/m2
(upper half) 157,21 157,21 24,00
0085
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
DESCRIPCION
m
m
m
m2
3,60 3,60
(upper half) 10,18 10,18
SYSTEM Nº 4 011-D-0001 011-D-0002 011-G-0008 A/B (2 Units)
26,00 26,00 3,00
4,00
LATERAL SURFACE
(upper half) 147,03 147,03
L/min
HIDRAULIC GRADIENT(3) 10% L/min
L/min
m3/h
6,00 6,00 20,40
943,23 943,23 489,60
94,32 94,32 48,96
1037,55 1037,55 538,56
62,25 62,25 32,31
TOTAL SYSTEM
2.376,06
2.613,67
156,82
2.613,67
156,82
TOTAL REQUIRED
2.613,67
156,82
11.520,00
691,20
TOTAL REQUIRED
11.520,00
691,20
2.613,67 11.520,00
156,82 691,20
14.133,67
848,02
TOTAL FLOW
TOTAL SYSTEM
TOTAL SYSTEM FIREWATER DEMANDS SYSTEM Nº 4 REQUIRED DELUGE SYSTEMS
REQUIRED MONITORS
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
6
FIREWATER DEMANDS UNIT FLOW
1.920,00
2 6
TOTAL TO BE INSTALLED
DISTANCE FROM MONITOR TO EQUIPMENT
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 08
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-A-0005
-
x
-
EL. 119000
0068
17m
0069
15m
0085
17m
-
-
011-D-0001
X
-
-
CL. 105330
-
-
-
-
-
-
011-D-0002
X
-
-
CL. 105330
-
-
-
-
011-G-0008A/B
X
-
-
BP. 100300
-
-
-
-
-
-
011-G-0025
-
-
x
BP. 100300
0073
15,5m
-
-
-
-
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
-
x
-
0082
23,3 m
0080
16,23 m
-
-
-
-
0068
0069
0080
0085
0073
0082
BOTTON SURFACE
LATERAL SURFACE
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2 (upper half) 10,18 10,18
m2 (upper half) 157,21 157,21 24,00
L/min/m2
(upper half) 147,03 147,03
Equipment involved on fire:
Equipment fire exposed: 011-G-0002A
BP. 100300
-
-
MONITORS WORKED IN SCENARIO
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
DESCRIPCION
m
m
m
SYSTEM Nº 4 011-D-0001 011-D-0002 011-G-0008 A/B (2 Units)
26,00 26,00 3,00
3,60 3,60 4,00
L/min
HIDRAULIC GRADIENT(3) 10% L/min
L/min
m3/h
6,00 6,00 20,40
943,23 943,23 489,60
94,32 94,32 48,96
1037,55 1037,55 538,56
62,25 62,25 32,31
TOTAL SYSTEM
2.376,06
2.613,67
156,82
2.613,67
156,82
TOTAL REQUIRED
2.613,67
156,82
11.520,00
691,20
TOTAL REQUIRED
11.520,00
691,20
2.613,67 11.520,00
156,82 691,20
14.133,67
848,02
TOTAL FLOW
TOTAL SYSTEM
TOTAL SYSTEM FIREWATER DEMANDS REQUIRED DELUGE #¡REF! SYSTEMS
REQUIRED MONITORS
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
6
FIREWATER DEMANDS UNIT FLOW
1.920,00
1 6
TOTAL TO BE INSTALLED
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 09
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-A-0005
-
x
-
EL. 119000
0068
17m
0069
15m
0085
17m
-
-
011-D-0001
X
-
-
CL. 105330
-
-
-
-
011-D-0002
X
-
-
CL. 105330
-
-
-
-
011-G-0002A
-
x
-
BP. 101000
0082
23,3 m
0080
16,23 m
-
-
-
-
011-G-0002B
-
x
-
BP. 101000
-
-
0082
22 m
0084
22m
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
-
-
-
Equipment involved on fire:
Equipment fire exposed: 011-A-0003
-
-
x
EL. 119000
0079
18m
0070
22,5 m
-
011-A-0004
-
-
x
EL. 119000
0079
23m
0070
27 m
-
-
011-G-0001A
-
x
-
BP. 101000
0079
21m
0082
22 m
0085
18 m
011-G-0025
-
-
x
BP. 100300
0073
15,5m
-
-
-
-
0068
0069
0080
0082
0084
0085
BOTTON SURFACE
LATERAL SURFACE
m2 (upper half) 10,18 10,18
(upper half) 147,03 147,03
MONITORS WORKED IN SCENARIO
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
DESCRIPCION
m
m
m
SYSTEM Nº 4 011-D-0001 011-D-0002 011-G-0008 A/B (2 Units)
26,00 26,00 3,00
3,60 3,60 4,00
0070
0079
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2 (upper half) 157,21 157,21 24,00
L/min/m2 6,00 6,00 20,40
TOTAL SYSTEM
L/min
HIDRAULIC GRADIENT(3) 10% L/min
L/min
m3/h
943,23 943,23 489,60
94,32 94,32 48,96
1037,55 1037,55 538,56
62,25 62,25 32,31
2.613,67
156,82
2.613,67
156,82
TOTAL REQUIRED
2.613,67
156,82
13.440,00
806,40
TOTAL REQUIRED
13.440,00
806,40
2.613,67 13.440,00
156,82 806,40
16.053,67
963,22
2.376,06
TOTAL FLOW
TOTAL SYSTEM FIREWATER DEMANDS
REQUIRED DELUGE SYSTEMS
REQUIRED MONITORS
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
7
FIREWATER DEMANDS UNIT FLOW
1.920,00
1 7
TOTAL TO BE INSTALLED
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 10
Equipment involved on fire:
01
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
-
-
x
EL. 119000
0079
18m
0070
22,5 m
-
-
-
-
011-A-0003 011 A 0004 011-A-0004
-
-
x
EL 119000 EL.
0079
23m
0070
27 m
011-A-0005
-
x
-
EL. 119000
0080
23m
0085
17m
011-A-0006
-
-
x
EL. 119000
0079
24m
0084
22m
-
-
011-D-0018
-
x
-
CL. 108800
0078
18m
0080
15,5m
-
-
011-G-0001A/B
-
x
-
CL. 101000
0079
21m
0082
22 m
0085
19m
011-G-0002A/B
-
x
-
CL. 101000
0082
23,3 m
0080
16,23 m
0084
21m
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
0082
0084
Equipment fire exposed: 01
ELEVATION
011-D-0001
X
-
-
CL. 105300
-
-
-
-
011-D-0002
X
-
-
CL. 105300
-
-
-
-
011-G-0026B
-
x
-
BP. 100300
0078
19m
0084
19m
0070
0078
0079
0080
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
MONITORS WORKED IN SCENARIO
0085
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
DESCRIPCION
m
m
m
SYSTEM Nº 4 011-D-0001 011-D-0002 011-G-0008 A/B (2 Units)
26,00 26,00 3,00
3,60 3,60
L/min
HIDRAULIC GRADIENT(3) 10% L/min
L/min
m3/h
6,00 6,00 20,40
943,23 943,23 489,60
94,32 94,32 48,96
1037,55 1037,55 538,56
62,25 62,25
TOTAL SYSTEM
2.376,06
2.613,67
156,82
2.613,67
156,82
TOTAL REQUIRED
2.613,67
156,82
13.440,00
806,40
TOTAL REQUIRED
13.440,00
806,40
2.613,67 13.440,00
156,82 806,40
16.053,67
963,22
BOTTON SURFACE
LATERAL SURFACE
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2 (upper half) 10,18 10,18
m2 (upper half) 157,21 157,21 24,00
L/min/m2
(upper half) 147,03 147,03
4,00
TOTAL FLOW
TOTAL SYSTEM FIREWATER DEMANDS
REQUIRED DELUGE SYSTEMS
REQUIRED MONITORS
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
7
FIREWATER DEMANDS UNIT FLOW
1.920,00
1 7
TOTAL TO BE INSTALLED
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 11
Equipment involved on fire:
01
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
-
-
-
-
-
-
011-C-0003
X
TL. 111500
0083
15 m
0076
21 m
011-D-0008
X
CL. 108500
0051
15,75 m
0053
17,5 m
-
-
011-D-0009
X
011-G-0017 A/B
X
TL. 111400
0051
24m
BP. 100300
-
-
011-G-0018 A/B
X
BP. 10300
0052
22,6 n
0053
23 m
-
-
011-S-0002
X
BP. 100300
0053
28 m
0051
28 m
-
-
BP. 100300
0083
21 m
0051
27 m
-
-
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
-
0057
0058
011-S-0001
X FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
011-D-0016
-
-
x
TL. 107000
0051
28m
-
011-D-0017
-
-
x
TL. 114000
0051
24m
-
-
011-F-0001
-
x
-
TOS. 103000
0057
15m
0058
15m
Equipment fire exposed:
01
011-F-0002
-
x
-
TOS. 103000
0056
15m
0057
15m
011-G-0015B
-
x
-
BP. 100300
0052
15m
0053
18m
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
MONITORS WORKED IN SCENARIO
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
DESCRIPCION
m
m
m
m2
0051
0053
0076
0083
0054
0056
LATERAL SURFACE
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2
L/min/m2
L/min
HIDRAULIC GRADIENT(3) 10% L/min
L/min
20,40 20,40
543,45 543,45
54,35 54,35
597,80 597,80
TOTAL SYSTEM
543,45
TOTAL FLOW m3/h
SYSTEM Nº 3 011-G-0017A 011-G-0017B
1.195,59
71,74
SYSTEM WATER COURTAIN FURNACE
1245,00
TOTAL SYSTEM REQUIRED DELUGE SYSTEMS
REQUIRED MONITORS
124,50
1245,00
SYSTEM Nº 3 SYSTEM
MONITOR
QUANT:
8
FIREWATER DEMANDS UNIT FLOW
1.920,00
TOTAL REQUIRED DELUGE SYSTEMS MONITORS
QUANT: QUANT:
2 8
TOTAL TO BE INSTALLED
1369,50
1.369,50
82,17
1.195,59 1.369,50
71,74 82,17
2.565,09
153,91
15.360,00
921,60
15.360,00
921,60
2.565,09 15.360,00
153,91 921,60
17.925,09
1.075,51
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 12
Equipment involved on fire:
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
-
X
-
TL. 111500
0054
16 m
0076
15,6 m
-
-
TL. 111500
0083
15 m
0076
21 m
-
-
-
-
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
-
-
0058
0076
011-C-0002 011-C-0003
X
011-D-0015
-
-
x
TL. 114000
011-G-0017A/B
x
-
-
BP. 100810
-
-
-
-
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
-
x
-
TOS. 100300
0057
15m
0058
15m
BP. 10300
0052
22,6 n
0053
23 m
Equipment fire exposed: 011-F-0001 011-G-0018B
X
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
MONITORS WORKED IN SCENARIO 0051
0053
0054
0057
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2
L/min/m2
0083
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
DESCRIPCION
m
m
m
m2
LATERAL SURFACE
L/min
HIDRAULIC GRADIENT(3) 10% L/min
L/min
20,40 20,40
543,45 543,45
54,35 54,35
597,80 597,80
TOTAL SYSTEM
543,45
TOTAL FLOW m3/h
SYSTEM Nº 3 011-G-0017A 011-G-0017B
1.195,59
71,74
SYSTEM nº 4 WATER COURTAIN FURNACE
1245,00
TOTAL SYSTEM
124,50
1245 00 1245,00
SYSTEM Nº 3 REQUIRED DELUGE SYSTEM nº 4 SYSTEMS
REQUIRED MONITORS
MONITOR
QUANT:
7
FIREWATER DEMANDS UNIT FLOW
1.920,00
TOTAL REQUIRED DELUGE SYSTEMS MONITORS
QUANT: QUANT:
2 7
TOTAL TO BE INSTALLED
1369,50
1.369,50
82 17 82,17
1.195,59 1.369,50
71,74 82,17
2.565,09
153,91
13.440,00
806,40
13.440,00
806,40
2.565,09 13.440,00
153,91 806,40
16.005,09
960,31
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 13
01
Equipment involved on fire:
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
011-C-0002
-
x
-
011-E-0020F
-
x
-
01
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
TL. 111500
0054
15,5m
0076
15,5
CL. 105564
0058
18m
0059
16m
ELEVATION
011-G-0014A
x
-
-
BP. 100300
-
-
-
-
011-G-0017A/B
x
-
-
BP. 100810
-
-
-
-
Equipment fire exposed:
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-C-0003
-
x
-
TL. 111500
0076
22m
0083
011-C-0005
-
-
x
TL. 123700
0055
15,5m
-
25m
011-C-0006
-
x
-
TL. 109000
0055
15,5m
0074
011-E-0020C/D/E
-
x
-
CL. 105564
0058
22m
0059
20m
011-F-0001
-
x
-
TOS. 103000
0057
15m
0058
15m
011-G-0013A/B
-
x
-
BP. 100300
0074
24m
0054
27m
011-G-0014B
x
-
-
BP. 100300
-
-
-
-
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
0074
0076
MONITORS WORKED IN SCENARIO 0054
0055
0058
0059
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2
L/min/m2
0083
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
DESCRIPCION
m
m
m
m2
LATERAL SURFACE
L/min
HIDRAULIC GRADIENT(3) 10% L/min
L/min
m3/h
20,40
342,73 342,73
34,27 34,27
377,00 377,00
22,62 22,62
TOTAL SYSTEM
685,45
754,00
45,24
20,40 20,40
543,45 543,45
TOTAL SYSTEM
543,45
TOTAL FLOW
SYSTEM Nº 2 011-G-00014A 011-G-00014B
SYSTEM Nº 3 011-G-0017A 011-G-0017B
54,35 54,35
597,80 597,80 1.195,59
71,74
SYSTEM nº 4 WATER COURTAIN FURNACE
1245,00
TOTAL SYSTEM
124,50
1245,00
1369,50
1.369,50
82,17
754,00 1.195,59 1.369,50
45,24 71,74 116,98
3.319,09
188,71
FIREWATER DEMANDS SYSTEM Nº 2 REQUIRED DELUGE SYSTEM Nº 3 SYSTEMS WATER COURTAIN FURNACE
REQUIRED MONITORS
MONITOR
QUANT:
5
FIREWATER DEMANDS UNIT FLOW
1.920,00
TOTAL REQUIRED DELUGE SYSTEMS MONITORS
QUANT: QUANT:
3 5
TOTAL TO BE INSTALLED
9.600,00
576,00
9.600,00
576,00
3.319,09 9.600,00
199,15 576,00
12.919,09
775,15
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 14 01
Equipment involved on fire:
01
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-C-0002
-
x
-
TL. 111500
0054
15,5m
0076
15,5
-
-
011-D-0005
-
x
-
CL. 109400
0073
24m
0074
15m
-
-
011-E-0019F
-
x
-
CL. 103150
0059
24m
0060
18m
-
-
011-E-0020A/B/C/D/E/F
-
x
-
CL. 103220
0058
17m
0059
15m
0060
23m
0073
22m
011-G-0011A/B
-
x
-
BP. 100300
0054
25,5m
0055
15m
011-G-0012A/B
-
x
-
BP. 100300
0054
27m
0073
22m
011-G-0014A/B
x
-
-
BP. 100300
-
-
-
-
-
-
Equipment fire exposed:
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-C-0005
-
-
x
TL. 123700
0055
15,5m
-
-
011-F-0001
-
X
-
TOS. 103000
0058
0060
0061
01
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
-
0059
011-C-0006
-
x
-
TL. 109000
0055
15,5m
0074
25m
011-D-0004
-
x
-
CL. 118500
0073
17m
0074
16m
011-D-0015
-
-
x
CL. 101950
0055
27m
-
-
011-E-0019D/E
-
x
-
CL. 103150
0060
20m
0061
21m
0074
17m
011-E-0021
-
-
x
CL. 116150
0073
17m
011-G-0009A
-
X
-
BP. 100300
0055
15m
-
011-G-0005A/B
-
x
-
BP. 100300
0055
18m
0073
18m
011-G-0010A
-
x
-
BP. 100300
0055
20M
0073
19m
011-G-0013A/B
-
x
-
BP. 100300
0074
24m
0054
27m
MONITORS WORKED IN SCENARIO
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
DESCRIPCION
m
m
m
m2
0054
0055
0058
0073
0074
0076
0059
LATERAL SURFACE
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2
L/min/m2
L/min
HIDRAULIC GRADIENT (3) 10% L/min
L/min
m3/h
20,40
342,73 342,73
34,27 34,27
377,00 377,00
22,62 22,62
TOTAL SYSTEM
685,45
754,00
45,24
TOTAL FLOW
SYSTEM Nº 2 011-G-00014A 011-G-00014B
SYSTEM nº 4 WATER COURTAIN FURNACE
1245 00 1245,00
124 50 124,50
TOTAL SYSTEM
1369 50 1369,50
1.369,50
82,17
754,00 1.369,50
45,24 82,17
TOTAL REQUIRED
2.123,50
127,41
17.280,00
1.036,80
TOTAL REQUIRED
17.280,00
1.036,80
2.123,50 17.280,00
127,41 1.036,80
19.403,50
1.164,21
FIREWATER DEMANDS SYSTEM Nº 2 REQUIRED DELUGE SYSTEM nº 4 SYSTEMS
REQUIRED MONITORS
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
9
FIREWATER DEMANDS UNIT FLOW
1.920,00
2 9
TOTAL TO BE INSTALLED
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 15
Equipment involved on fire:
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
22m
011-G-0013A/B
-
x
-
BP. 100300
0074
24m
0054
27m
011-G-0011A/B
-
x
-
BP. 100300
0054
25,5m
0055
15m
0073
011-G-0014B
x
-
-
BP. 100300
-
-
-
-
-
-
011 G 0012A/B 011-G-0012A/B
-
x
-
BP 100300 BP.
0054
27m
0073
22m
0055
15m
011-G-0005A/B
-
x
-
BP. 100300
0055
18m
0073
18m
011-G-0010A/B
-
x
-
BP. 100300
0055
20M
0073
19m
011-E-0020A/B/C/D/E/F
-
x
-
CL. 103220
0058
17m
0059
15m
0060
23m
011-E-0019A/B/C/D/E
-
x
-
CL. 103150
0060
20m
0059
24m
0062
23m
011-D-0005
-
x
-
CL. 109400
0073
17m
0074
15m
-
-
011-D-0004
-
x
-
CL. 118550
0073
17m
0074
16m
CL. 116150
0073
17m
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-E-0021
-
-
x
Equipment fire exposed:
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
-
011-C-0005
-
-
x
TL. 123700
0055
15,5m
-
-
011-C-0006
-
x
-
TL. 109000
0055
15,5m
0074
25m
011-G-0009A
-
X
-
BP. 100300
0055
15m
0074
17m
011-G-0014A
x
-
-
BP. 100300
-
-
-
-
-
-
011-E-0020F
-
x
-
CL. 103220
0058
17m
0059
15m
0060
20m
011-G-0008A/B
X
-
-
BP. 100300
-
-
-
-
-
-
011-E-0018 C/D
-
X
-
CL. 105139,5
0060
-
-
-
0054
0055
0060
0062
0073
0074
LATERAL SURFACE
MONITORS WORKED IN SCENARIO
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
DESCRIPCION
m
m
m
m2
0058
0059
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2
L/min/m2
L/min
HIDRAULIC GRADIENT(3) 10% L/min
L/min
m3/h
6,00 6,00
943,23 943,23
94,32 94,32
1.037,55 1.037,55
62,25 62,25
TOTAL SYSTEM
1.886,46
2.613,67
156,82
TOTAL FLOW
TOTAL SYSTEM
SYSTEM Nº 4 011-D-0001 011-D-0002
26,00 26,00
3,60 3,60
(upper half) 10,18 10,18
(upper half) 147,03 147,03
(upper half) 157,21 157,21
011-G-0008 A/B (2 Units)
FIREWATER DEMANDS REQUIRED DELUGE SYSTEMS
REQUIRED MONITORS
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
8
FIREWATER DEMANDS UNIT FLOW
2.613,67
156,82
TOTAL REQUIRED
2.613,67
156,82
15.360,00
921,60
TOTAL REQUIRED
15.360,00
921,60
2.613,67 15.360,00
156,82 921,60
17.973,67
1.078,42
1.920,00
1 8
TOTAL TO BE INSTALLED
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 16
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
-
x
-
CL. 118550
0073
17m
0074
16m
-
-
-
X
-
CL. 109400
0073
24m
0074
15m
-
Equipment involved on fire:
FIXED SPRAY SYSTEM
011-D-0004 011-D-0005 011-E-0017B
-
-
x
CL. 102900
0062
18m
-
-
-
011-E-0018C/D
-
-
x
CL. 105439,5
0060
16m
-
-
-
-
011-E-0019A/B/C/D/E/F
-
X
-
CL. 105439,5
0060
15m
0061
15m
0059
22m
011-E-0021
-
X
CL. 116,150
0073
17m
0074
15m
-
011-G-0005A/B
-
X
-
BP. 100300
0055
18m
0073
18m
-
011-G-0008A/B
x
-
-
BP. 100300
-
-
-
-
-
011-G-0010A/B
-
X
-
BP. 100300
0055
19m
0073
15,5m
-
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
-
-
011-G-0011B
-
x
-
BP. 100300
0054
25,5m
0055
15m
0073
011-G-0012B
-
X
-
BP. 100300
0054
27m
0073
22m
0055
22m 15m
Equipment fire exposed:
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-D-0001
x
-
-
CL. 105330
-
-
-
-
-
-
011-E-0016B
-
-
x
CL. 103150
0062
15,5m
-
-
-
-
011-E-0018A/B
-
-
x
CL. 105439,5
0062
15,5m
-
-
-
-
011-E-0020A/B
-
x
-
CL. 103220
0059
21m
0060
20m
-
-
011-G-0011A
-
x
-
BP. 100300
0054
25,5m
0055
15m
0073
27m
011-G-0012A
-
X
-
BP. 100300
0054
27m
0073
22m
0055
15m
0062
0069
L/min
m3/h
1.037,55 1.037,55
62,25 62,25
2.662,24
159,73
MONITORS WORKED IN SCENARIO
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
DESCRIPCION
m
m
m
m2
0054
0055
0073
0074
0059
0061
LATERAL SURFACE
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2
L/min/m2
L/min
HIDRAULIC GRADIENT (3) 10% L/min
6,00 6,00
943,23 943,23
94,32 94,32
TOTAL SYSTEM
1.886,46
TOTAL FLOW
TOTAL SYSTEM
SYSTEM Nº 4 011-D-0001 011-D-0002
26,00 26,00
3,60 3,60
(upper half) 10,18 10,18
(upper half) 147,03 147,03
(upper half) 157,21 157,21
011-G-0008 A/B (2 Units)
FIREWATER DEMANDS REQUIRED DELUGE SYSTEM Nº 4 SYSTEMS
REQUIRED MONITORS
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
8
FIREWATER DEMANDS UNIT FLOW
2.662,24
159,73
TOTAL REQUIRED
2.662,24
159,73
15.360,00
921,60
TOTAL REQUIRED
15.360,00
921,60
2.662,24 15.360,00
159,73 921,60
18.022,24
1.081,33
1.920,00
1 8
TOTAL TO BE INSTALLED
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 17
01
Equipment involved on fire:
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-E-0004A
-
-
x
CL. 116750
0063
26m
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
-
-
-
-
-
011-E-0017B
-
-
x
CL. 102900
0062
18m
-
-
-
-
-
-
011 E 0018C/D 011-E-0018C/D
-
-
x
CL 105439 CL. 105439,5 5
0060
16m
-
-
-
-
-
-
011-E-0019A/B/C/D/E/F
-
X
-
CL. 105449,5
0060
15m
0061
21m
0059
Equipment fire exposed:
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-D-0003
-
-
x
CL. 109000
0063
20m
-
-
011-E-0004B
-
-
x
CL. 116750
0063
20m
-
-
011-E-0016B
-
-
x
CL. 103150
0062
15,5m
-
-
011-E-0018A/B
-
-
x
CL. 105439,5
0062
15,5m
-
-
01
011-G-0008A/B
x
-
-
BP. 100300
-
-
-
-
011-G-0010A/B
-
x
-
BP. 100300
0055
19m
0073
15,5m
011-G-0012A/B
-
x
-
BP. 100300
0054
27m
0073
22m
0054
0055
0063
0073
LATERAL SURFACE
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
-
-
0055
15m
0061
0062
-
-
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
MONITORS WORKED IN SCENARIO
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
DESCRIPCION
m
m
m
m2
3,60 3,60
(upper half) 10,18 10,18
SYSTEM Nº 4 011-D-0001 011-D-0002 011-G-0008 A/B (2 Units)
26,00 26,00 3,00
4,00
(upper half) 147,03 147,03
0059
0060
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2
L/min/m2
(upper half) 157,21 157,21 24,00
6,00 6,00 20,40
TOTAL SYSTEM
L/min
HIDRAULIC GRADIENT(3) 10% L/min
L/min
m3/h
943,23 943,23 489,60
94,32 94,32 48,96
1037,55 1037,55 538,56
62,25 62,25
2.613,67
156,82
2.613,67
156,82
TOTAL REQUIRED
2.613,67
156,82
15.360,00
921,60
TOTAL REQUIRED
15.360,00
921,60
2.613,67 15.360,00
156,82 921,60
17.973,67
1.078,42
1.432,83
TOTAL FLOW
TOTAL SYSTEM FIREWATER DEMANDS REQUIRED DELUGE SYSTEMS
REQUIRED MONITORS
SYSTEM Nº 4
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
8
FIREWATER DEMANDS UNIT FLOW
1.920,00
1 8
TOTAL TO BE INSTALLED
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 18
Equipment involved on fire:
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-E-0019A/B
-
x
-
CL. 105449,5
0060
20m
0061
15m
011-E-0018A/B/C/D
-
-
x
CL. 105439,5
0062
15,5m
0060
16m
011-E-0017B
-
-
x
CL. 102900
0062
15,5m
011-E-0016B
-
-
x
CL. 103150
0062
17m
-
-
011-G-0008A/B
x
-
-
BP. 100300
-
-
-
-
011-D-0003
-
-
x
CL. 109000
0063
20m
-
-
011-E-0004A/B
-
-
x
CL. 116750
0063
26m
-
-
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
Equipment fire exposed: 011-E-0019C
-
x
-
CL. 103150
0060
20m
0061
15m
011-G-0010B
-
x
-
BP. 100300
0055
23m
0073
15,5m
011-G-0005B
-
x
-
BP. 100300
0055
23m
0073
15,5m
011-E-0016A
-
-
x
CL. 103150
0062
15,5m
-
-
011-E-0015A/B
-
-
x
CL. 105314,5
0062
15,5m
-
-
0055
0060
0061
0062
LATERAL SURFACE
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2
L/min/m2
(upper half) 157,21 157,21 24,00
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
0063
0073
MONITORS WORKED IN SCENARIO
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
DESCRIPCION
m
m
m
m2
3,60 3,60
(upper half) 10,18 10,18
SYSTEM Nº 4 011-D-0001 011-D-0002 011-G-0008 A/B (2 Units)
26,00 26,00 3,00
4,00
(upper half) 147,03 147,03
L/min
HIDRAULIC GRADIENT(3) 10% L/min
L/min
m3/h
6,00 6,00 20,40
943,23 943,23 489,60
94,32 94,32 48,96
1037,55 1037,55 538,56
62,25 62,25 32,31
TOTAL SYSTEM
2.376,06
TOTAL FLOW
2.613,67
TOTAL SYSTEM FIREWATER DEMANDS REQUIRED DELUGE SYSTEMS
REQUIRED MONITORS
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
6
FIREWATER DEMANDS UNIT FLOW
2.613,67
156,82
TOTAL REQUIRED
2.613,67
156,82
11.520,00
691,20
TOTAL REQUIRED
11.520,00
691,20
2.613,67 11.520,00
156,82 691,20
14.133,67
848,02
1.920,00
1 6
TOTAL TO BE INSTALLED
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 19
01
See note
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-E-0004A
-
-
x
CL. 116750
0063
26m
-
-
011 E 0015A/B 011-E-0015A/B
-
-
x
CL 105314 CL. 105314,5 5
0062
16m
-
-
011-E-0016A/B
-
-
x
CL. 103150
0062
15m
-
-
011-E-0017A
-
-
x
CL. 102900
0062
15m
-
-
011-E-0018A/B
-
-
x
CL. 105439,5
0062
15,5m
0060
16m
011-G-0003A/B
x
-
-
BP. 100300
-
-
-
-
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
Equipment fire exposed:
01 See note
Equipment involved on fire:
(*)
(*)
ELEVATION
011-D-0003
-
-
x
CL. 109000
0063
20m
-
-
011-E-0017B
-
-
x
CL. 102900
0062
18m
-
-
011-E-0018C/D
-
-
x
CL. 105439,5
0060
18m
-
-
011-G-0008B
x
-
-
BP. 100300
-
-
-
-
011-E-0004B
-
-
x
CL. 116750
0063
26m
-
-
0060
0062
0063
LATERAL SURFACE
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2
L/min/m2
12,00 12,00 51,00 51,00
20,40 20,40 20,40 20,40
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
MONITORS WORKED IN SCENARIO
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
DESCRIPCION
m
m
m
m2
4,00 4,00 10,20 10,20
3,00 3,00 5,00 5,00
L/min
HIDRAULIC GRADIENT(3) 10% L/min
L/min
m3/h
244,80 244,80 1.040,40 1.040,40
24,48 24,48 104,04 104,04
269,28 269,28 1.144,44 1.144,44
16,16 16,16 68,67 68,67
2.827,44
169,65
1037,55 1037,55 538,56
62,25 62,25 32,31
2.613,67
156,82
2.827,44 2.613,67
169,65 156,82
TOTAL REQUIRED
5.441,11
326,47
5.760,00
345,60
TOTAL REQUIRED
5.760,00
345,60
5.441,11 5.760,00
326,47 345,60
11.201,11
672,07
TOTAL FLOW
SYSTEM Nº 5 011-G-0003A 011-G-0003B 011-G-0004A 011-G-0004B
TOTAL SYSTEM
SYSTEM Nº 4 011-D-0001 011-D-0002 011-G-0008 A/B (2 Units)
26,00 26,00 3,00
3,60 3,60
(upper half) 10,18 10,18
4,00
(upper half) 147,03 147,03
(upper half) 157,21 157,21 24,00
6,00 6,00 20,40
TOTAL SYSTEM
2.570,40
943,23 943,23 489,60
94,32 94,32 48,96
2.376,06
FIREWATER DEMANDS SYSTEM Nº 5 REQUIRED DELUGE SYSTEM Nº 4 SYSTEMS
REQUIRED MONITORS
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
3
FIREWATER DEMANDS UNIT FLOW
1.920,00
2 3
TOTAL TO BE INSTALLED
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 20
Equipment involved on fire:
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-E-0015A/B
-
-
x
CL. 105315,5
0062
16m
-
-
011-E-0016A
-
-
x
CL. 103150
0062
15m
-
011-G-0003A/B
x
-
-
BP. 100300
-
-
-
-
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
Equipment fire exposed: 011-E-0017A
-
-
x
CL. 102900
0062
15m
-
-
011-E-0018A/B
-
-
x
CL. 105439,5
0062
15,5m
-
-
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
MONITORS WORKED IN SCENARIO 0062
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
DESCRIPCION
m
m
m
m2
4,00 4,00 10,20 10,20
3,00 3,00 5,00 5,00
LATERAL SURFACE
L/min
HIDRAULIC GRADIENT(3) 10% L/min
L/min
m3/h
20,40 20,40 20,40 20,40
244,80 244,80 1.040,40 1.040,40
24,48 24,48 104,04 104,04
269,28 269,28 1.144,44 1.144,44
16,16 16,16 68,67 68,67
TOTAL SYSTEM
2.080,80
2.827,44
169,65
2.827,44
169,65
TOTAL REQUIRED
2.827,44
169,65
1.920,00
115,20
TOTAL REQUIRED
1.920,00
115,20
2.827,44 1.920,00
169,65 115,20
4.747,44
284,85
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2
L/min/m2
12,00 12,00 51,00 51,00
TOTAL FLOW
SYSTEM Nº 5 011-G-0003A 011-G-0003B 011-G-0004A 011-G-0004B
TOTAL SYSTEM FIREWATER DEMANDS REQUIRED DELUGE SYSTEMS
REQUIRED MONITORS
SYSTEM Nº 5
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
1
FIREWATER DEMANDS UNIT FLOW
1.920,00
1 1
TOTAL TO BE INSTALLED
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 21
Equipment involved on fire:
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEBVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-C-0001
x
-
-
TL. 111500
-
-
-
-
011 D 0003 011-D-0003
-
-
x
CL 109000 CL.
0063
20m
-
-
011-E-0004A/B
-
-
x
CL. 116750
0063
26m
-
-
011-E-0015A/B
-
-
x
CL. 105314,5
0062
16m
-
-
011-E-0016A/B
-
-
x
CL. 103150
0062
15m
-
-
011-E-0017A
-
-
x
CL. 102900
0062
15m
-
-
011-E-0018A/B
-
-
x
CL. 105139,5
0062
15,5m
-
-
011-G-0003A/B
x
-
-
BP. 100300
-
-
-
-
011-G-0004A/B
x
-
-
BP. 100300
-
-
-
-
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
Equipment fire exposed:
ELEVATION
011-E-0017B
-
-
x
CL. 102900
0060
18m
-
-
011-E-0018C/D
-
-
x
CL. 105439,5
0060
16m
-
-
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
MONITORS WORKED IN SCENARIO
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
DESCRIPCION
m
m
m
m2
4,00 4,00 10,20 10,20
3,00 3,00 5,00 5,00
0060
0062
0063
LATERAL SURFACE
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2
L/min/m2
12,00 12,00 51,00 51,00
L/min
HIDRAULIC GRADIENT(3) 10% L/min
L/min
m3/h
20,40 20,40 20,40 20,40
244,80 244,80 1.040,40 1.040,40
24,48 24,48 104,04 104,04
269,28 269,28 1.144,44 1.144,44
16,16 16,16 68,67 68,67
TOTAL SYSTEM
2.570,40
2.827,44
169,65
10,20
2.042,82
2.247,10
134,83
TOTAL SYSTEM
2.042,82
2.247,10
134,83
2.827,44 2.247,10
169,65 134,83
TOTAL REQUIRED
5.074,54
304,47
5.760,00
345,60
TOTAL REQUIRED
5.760,00
345,60
5.074,54 5.760,00
304,47 345,60
10.834,54
650,07
TOTAL FLOW
SYSTEM Nº 5 011-G-0003A 011-G-0003B 011-G-0004A 011-G-0004B
SYSTEM Nº 7 011-C-0001
8,50
7,50
200,28
200,28
204,28
FIREWATER DEMANDS SYSTEM Nº 5 REQUIRED DELUGE SYSTEM Nº 7 SYSTEMS
REQUIRED MONITORS
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
3
FIREWATER DEMANDS UNIT FLOW
1.920,00
2 3
TOTAL TO BE INSTALLED
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 22
Equipment involved on fire:
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-E-0015A/B
-
-
x
CL. 105314,5
0062
16m
-
-
011-E-0016A/B
-
-
x
CL. 103150
0062
15m
-
-
011-E-0017A
-
-
x
CL. 102900
0062
15m
-
-
011-E-0018A/B
-
-
x
CL. 105439,5
0062
15,5m
-
-
011-G-0025
-
-
x
ON TOP D-0014
0073
15,5m
-
-
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
CL.105330
-
-
-
-
Equipment fire exposed: 011-D-0001
x
-
-
011-D-0002
x
-
-
CL.105330
-
-
-
-
011-E-0017B
-
-
x
CL. 102900
0062
18m
-
-
011-E-0018C/D
-
-
x
CL. 105439,5
0060
16m
-
-
011-G-0008B
x
-
-
BP. 100300
-
-
-
-
0060
0062
0073
LATERAL SURFACE
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2
L/min/m2
(upper half) 157,21 157,21 24,00
6,00 6,00 20,40
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
MONITORS WORKED IN SCENARIO
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
DESCRIPCION
m
m
m
m2
3,60 3,60
(upper half) 10,18 10,18
SYSTEM Nº 4 011-D-0001 011-D-0002 011-G-0008 A/B (2 Units)
26,00 26,00 3,00
4,00
(upper half) 147,03 147,03
L/min
HIDRAULIC GRADIENT(3) 10% L/min
L/min
m3/h
943,23 943,23 489,60
94,32 94,32 48,96
1037,55 1037,55 538,56
62,25 62,25 32,31
2.613,67
156,82
2.376,06
TOTAL FLOW
FIREWATER DEMANDS REQUIRED DELUGE SYSTEMS S S S
REQUIRED MONITORS
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
3-Jan-00
FIREWATER DEMANDS UNIT FLOW
2.613,67
156,82
TOTAL REQUIRED
2 613 67 2.613,67
156 82 156,82
5.760,00
345,60
TOTAL REQUIRED
5.760,00
345,60
2.613,67 5.760,00
156,82 345,60
8.373,67
502,42
1.920,00
2-Jan-00 3-Jan-00
TOTAL TO BE INSTALLED
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 23
Equipment involved on fire:
01
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
011-A-0003
-
-
x
EL. 119000
0079
18m
-
-
-
-
-
-
-
-
x
EL. 119000
0079
23m
-
-
-
-
-
-
011-A-0005 A/B
-
x
-
EL. 119000
0068
17m
0069
15m
0085
23m
-
-
011-A-0006
-
-
x
EL. 119000
0079
24m
0084
22m
-
-
-
-
011-E-0002
-
-
x
CL. 102750
0070
25m
-
-
-
-
-
-
011-E-0007A/B/C/D
-
-
x
CL. 105160
0068
24m
-
-
-
-
-
-
011-E-00008
-
-
x
CL. 103275
0068
18m
-
-
-
-
-
-
011-E-0009A/B
-
-
x
CL. 102700
0069
26m
-
-
-
-
-
-
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
See note (*)
011-D-0001
x
-
-
CL. 105330
-
-
-
-
-
-
011-D-0002
x
-
-
CL. 105330
-
-
-
-
-
-
011-D-0018
-
x
-
CL. 108800
0078
18m
0080
15,5m
-
-
011-E-0001
-
-
x
CL. 102950
0070
21m
-
-
-
-
011-E-0006
-
-
x
CL. 103275
0068
20m
-
-
-
011-E-0023
-
-
x
CL. 102180
0070
16,5m
-
-
-
-
011-G-0001A/B
-
x
-
BP. 101000
0079
21m
0082
22 m
0085
18 m
011-G-0002A/B
-
x
-
BP. 101000
0082
23m
0084
18m
-
-
011-G-0026A/B
-
x
-
BP. 100300
0078
19m
0080
17m
-
-
0085
0084
MONITORS WORKED IN SCENARIO
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
m
m
DESCRIPCION
DIAMETER m
SYSTEM Nº 4 011-D-0001 011-D-0002 011-G-0008 A/B (2 Units)
26,00 26,00 3,00
3,60 3,60
0079
0068
0070
0082
BOTTON SURFACE
LATERAL SURFACE
m2 (upper half) 10,18 10,18
(upper half) 147,03 147,03
4,00
0069
0080
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2 (upper half) 157,21 157,21 24,00
L/min/m2 6,00 6,00 20,40
TOTAL SYSTEM
2.376,06
L/min
HIDRAULIC GRADIENT (3) 10% L/min
L/min
m3/h
943,23 943,23 489,60
94,32 94,32 48,96
1037,55 1037,55 538,56
62,25 62,25 32,31
2.613,67
156,82
2.613,67
156,82
TOTAL REQUIRED
2.613,67
156,82
15.360,00
921,60
TOTAL REQUIRED
15.360,00
921,60
2.613,67 15.360,00
156,82 921,60
17.973,67
1.078,42
TOTAL FLOW
TOTAL SYSTEM FIREWATER DEMANDS
REQUIRED DELUGE SYSTEMS
REQUIRED MONITORS
DISTANCE FROM MONITOR TO EQUIPMENT
011-A-0004
Equipment fire exposed:
01
ELEVATION
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
8
FIREWATER DEMANDS UNIT FLOW
1.920,00
1 8
TOTAL TO BE INSTALLED
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 24
Equipment involved on fire:
01
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT -
011-D-0008
-
x
-
CL. 108450
0051
19,5m
0083
15,5m
-
011-D-0009
-
-
x
TL. 114000
0051
24m
-
-
-
-
011-D-0016
-
-
x
TL. 107000
0051
28m
-
-
-
-
-
-
011-D-0017
-
-
x
TL. 107000
0051
28m
-
-
011-G-0015A/B
-
x
-
TL. 114000
0052
15m
0053
18m
011-G-0016A/B
-
x
-
BP. 100300
0051
15m
0053
15m
-
-
011-G-0018A/B
-
x
-
BP. 100300
0052
23m
0053
22m
0054
24m
011-G-0020A/B
-
-
x
BP. 100300
0053
23m
-
-
-
-
011-K-0001
-
-
x
BP. 100300
0077
15 m
-
-
-
-
011-S-0001
-
-
x
TOS. 100300
0053
28 m
0051
28 m
-
-
011-S-0002
-
-
x
TOS. 100300
0083
21 m
0051
27 m
-
-
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
TL. 11500
0083
15 m
0076
21 m
-
-
0077
0083
Equipment fire exposed:
01
011-C-0003
-
x
-
MONITORS WORKED IN SCENARIO
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
DESCRIPCION
m
m
m
m2
0051
0052
0053
0054
LATERAL SURFACE
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2
L/min/m2
L/min
HIDRAULIC GRADIENT(3) 10% L/min
L/min
m3/h
15,00
300,00
30,00
330,00
19,80
TOTAL SYSTEM
300,00
330,00
19,80
330,00
19,80
TOTAL REQUIRED
330,00
19,80
11.520,00
691,20
TOTAL REQUIRED
11.520,00
691,20
330,00 11.520,00
19,80 691,20
11.850,00
711,00
TOTAL FLOW
SYSTEM Nº 1 Water courtain Compressors 151-K-0001
20,00
TOTAL SYSTEM FIREWATER DEMANDS REQUIRED DELUGE SYSTEMS
REQUIRED MONITORS
º
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
6,00
FIREWATER DEMANDS UNIT FLOW
1.920,00
1,00 6,00
TOTAL TO BE INSTALLED
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 25 01
01
Equipment involved on fire:
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-D-0008
-
x
-
CL. 108450
0051
15,75 m
0053
17,5 m
-
-
011-D-0009
-
-
x
TL. 114000
0051
24m
-
-
-
-
011-G-0015A/B
-
x
-
BP. 10300
0052
15m
0053
18m
011-G-0016A/B
-
x
-
BP. 100300
0051
15m
0053
15m
-
-
011-G-0018A/B
-
x
-
BP. 10300
0052
22,6 n
0053
23 m
011-S-0001
-
-
x
TOS. 100300
0053
28 m
0051
28 m
-
-
011-S-0002
-
-
x
TOS. 100300
0083
21 m
0051
27 m
-
-
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
Equipment fire exposed:
01
ELEVATION
011-C-0003
-
x
-
TL. 115000
0083
15 m
0076
21 m
-
-
011-F-0001
-
x
-
TOS. 103000
0057
15m
0058
15m
-
-
011-F-0002
-
x
-
TOS. 103000
0056
15m
0057
15m
-
-
0051
0052
0053
0083
0056
0057
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2
L/min/m2
L/min
MONITORS WORKED IN SCENARIO
0058
DELUGE VALVE STATION Nº
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
DESCRIPCION
m
m
m
m2
LATERAL SURFACE
HIDRAULIC GRADIENT(3) 10% L/min
TOTAL FLOW L/min
m3/h
TOTAL SYSTEM
TOTAL SYSTEM FIREWATER DEMANDS REQUIRED DELUGE SYSTEMS
REQUIRED MONITORS
º
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
7
FIREWATER DEMANDS UNIT FLOW
1.920,00
13.440,00
806,40
TOTAL REQUIRED
13.440,00
806,40
13.440,00
806,40
TOTAL TO BE INSTALLED
13.440,00
806,40
7
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 26
01
Equipment involved on fire:
FIXED SPRAY SYSTEM
DOUBLE COVERAGE MONITOR
SINGLE COVERAGE MONITOR
ELEVATION
PROTECTED BY MONITOR MLZ-
011-F-0001
-
x
-
TOS. 103000
Equipment fire exposed:
01
DISTANCE FROM MONITOR TO EQUIPMENT
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
0057
15m
0058
15m
ELEVATION
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
PROTECTED BY MONITOR MLZ-
DISTANCE FROM MONITOR TO EQUIPMENT
011-D-0015
-
-
x
CL. 101950
0055
27m
-
-
011-F-0002
-
x
-
TOS. 103000
0056
15m
0057
15m
011-G-0017B
x
-
-
BP, 100300
-
-
-
-
011-G-0018B
-
x
-
BP. 100300
0052
22,6 n
0053
23 m
MONITORS WORKED IN SCENARIO
DELUGE VALVE STATION Nº
0057
0058
0055
0056
0052
LATERAL SURFACE
TOTAL SURFACE
FLOW RATE(1)
FLOW
m2
L/min/m2
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
DESCRIPCION
m
m
m
m2
0053
L/min
HIDRAULIC GRADIENT(3) 10% L/min
L/min
m3/h
1.245,00
124,50
1.369,50
82,17
1.369,50
82,17
1.369,50
82,17
TOTAL REQUIRED
1.369,50
82,17
11.520,00
691,20
TOTAL REQUIRED
11.520,00
691,20
1.369,50 11.520,00
82,17 691,20
12.889,50
773,37
TOTAL FLOW
SYSTEM Nº 6 Water courtain F-0001, F-0002
TOTAL SYSTEM
1.245,00
FIREWATER DEMANDS REQUIRED DELUGE SYSTEMS
REQUIRED MONITORS
SYSTEM Nº 6
MONITOR
DELUGE SYSTEMS MONITORS
QUANT:
QUANT: QUANT:
6
FIREWATER DEMANDS UNIT FLOW
1.920,00
1 6
TOTAL TO BE INSTALLED
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801
TR Jubail
CRUDE DISTILLATION UNIT TRAIN 1 FIRE WATER DEMAND AFC
4. CONCLUSION
01
The fire water demand on CRUDE DISTILLATION UNIT TRAIN 1, has been evaluated on the basis of the maximum fire water flow need for the worst fire scenario associated to the risk area. The worst fire scenario has been evaluated considering the fire water flow required for the fire fighting measures needs for extinguishing the fire pool and cooling the involved and adjacent equipments. The scenario 16 is the worst scenario. The fire water flow needs for the Scenario 14 are 1.164,21 m3/h. CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 01 SCENARIO 02 SCENARIO 03 SCENARIO 04 SCENARIO 05 SCENARIO 06 SCENARIO 07 SCENARIO 08 SCENARIO 09 SCENARIO 10 SCENARIO 11 SCENARIO 12 SCENARIO 13 SCENARIO 14 SCENARIO 15 SCENARIO 16 SCENARIO 17 SCENARIO 18 SCENARIO 19 SCENARIO 20 SCENARIO 21 SCENARIO 22 SCENARIO 23 SCENARIO 24 SCENARIO 25 SCENARIO 26
TOTAL FLOW L/min 13.770,00 14.965,59 17.309,59 14.194,00 14.887,67 14.887,67 14.133,67 14.133,67 16.053,67 16.053,67 17.925,09 16.005,09 12.919,09 19.403,50 17.973,67 18.022,24 17.973,67 14.133,67 11.201,11 4.747,44 10.834,54 8.373,67 17.973,67 11 8 0 00 11.850,00 13.440,00 12.889,50
m3/h 826,20 897,94 1.038,58 851,64 893,26 893,26 848,02 848,02 963,22 963,22 1.075,51 960,31 775,15 1.164,21 1.078,42 1.081,33 1.078,42 848,02 672,07 284,85 650,07 502,42 1.078,42 711,00 11 00 806,40 773,37
01
DOCUMENT No.:
SA-JER-DS011-TRJR-675801
ATTACHMENT A1
TR Project No.: 02020
DOCUMENT No.:
SA-JER-DS011-TRJR-675801
ATTACHMENT A2
TR Project No.: 02020
JUBAIL EXPORT REFINERY PR PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-
1. INTRODUCTION Using the methodology defined by NFPA i.e.
o For adjacent pumps and compressors exposed to radia o For adjacent vessels and columns exposed to radiation surface area and a water spray density of 0.1 o For these radiant heat exposure calculations, any part o It means, for instance, for each pumps define the exact surface exposed to radiation For instance for a pump:
TAG NO
001-G-0001A/B
m2
50% OF SURFACE AREA m2
20.0
10.0
SURFACE AREA
L/m2s
REQUIRED WATER DEMAND L/s
0.34
3.4
DENSITY
We should obtain in that case for each piece of equipment exposed to radiation grea The sum of the water amount will be the water required to protect the pieces equipm To this water amount we will add the water density applied for the pool fire in the co For the area we are considering i.e. 1200 m2 this corresponds to 468 m3/h.
ROJECT -675801 CRUDE DISTILLATION UNIT TRAI FIRE WATER DEMAND AFC
tion greater than 12.5 kW/m2, from grade to a height of 7.5m, use 50% o greater than 12.5 kW/m2, from grade to a height of 7.5m, use 50% of th 10 L/m2/sec. of adjacent equipment more than 7.5m above grade can be ignored. greater than 13.5 kW/m2, from grade to a height of 7.5 m, consider only 50% of the surfac
m3/hr 12.24
ter than 12.5 kW/m2 the water required following the surface defined. ment from radiation greater than 13.5 kW/m2. onsidered area i.e. 6.5 l/min/m2 (according to NFPA 11‐ table 5.8.2.2, for non diked spill fir
Rev. No.
N1
of the surface area of the equipment and a water spray density of 0.34 L/m2s. he total vessel/column (including exchangers)
ce area and apply the water density of 0.34 L/m2.s to this surface.
res)
03
TR Jubail Refinery
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 01_NFPA
Equipment fire exposed:
DELUGE VALVE STATION Nº
ELEVATION
011-G-0015B
BP. 10300
011-D-0008
CL. 108450
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
DESCRIPCION
m
m
011-G-0015B 011-D-0008
2,15 7,10
5,00 3,10
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
10,75 79,71
0,34 0,10
5,38 39,86
1,83 3,99
6,58 14,35
5,81
20,93
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
348,79 7.800,00
20,93 468,00
8.148,79
488,93
40/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 02_NFPA
Equipment fire exposed:
DELUGE VALVE STATION Nº
ELEVATION
011-C-0007
TL. 106000
011-G-0018 B
BP. 100300
011-K-0001
BP, 100300
011-E-0022
CL. 106940
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DESCRIPCION
m
m
011-C-0007 011-G-0018 B 011-K-0001 011-E-0022
7,50 2,40 3,20 5,64
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
0,91 5,85 7,00 1,05
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
21,44 14,04 22,40 19,82
0,10 0,34 0,34 0,10
10,72 7,02 11,20 9,91
1,07 2,39 3,81 0,99
3,86 8,59 13,71 3,57
8,26
29,73
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
495,46 7.800,00
29,73 468,00
8.295,46
497,73
41/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 02_NFPA
Equipment fire exposed:
DELUGE VALVE STATION Nº
ELEVATION
011-C-0003
TL. 115000
011-G-0007A/B
BP. 100300
011-G-0009A/B
BP. 100300
011-G-0011A
BP. 100300
011-G-0013A/B
BP. 100300
011-G-0014B
BP. 100300
EQUIPMENT HAZARD
LENGTH HEIGHT
SEE NOTE
WIDTH
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
DESCRIPCION
m
m
011-G-0007A/B 011-G-0009A/B 011-G-0011A 011-G-0013A/B 011-G-0014B
9,60 5,25 3,35 5,09 2,40
6,78 3,85 1,70 3,06 5,85
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
65,09 20,20 5,68 15,55 14,05
0,34 0,34 0,34 0,34 0,34
32,54 10,10 2,84 7,78 7,02
11,06 3,43 0,97 2,64 2,39
39,83 12,36 3,48 9,52 8,60
20,50
73,79
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
1.229,86 7.800,00
73,79 468,00
9.029,86
541,79
42/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 0_NFPA
Equipment fire exposed:
DELUGE VALVE STATION Nº
ELEVATION
011-E-0021
CL. 116150
011-G-0005A
BP. 100300
SEE NOTE
011-G-0010A
BP. 100300
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DESCRIPCION
m
m
011-E-0021 011-G-0005A 011-G-0010A
5,81 3,20 5,63
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
1,50 1,85 2,08
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
29,83 5,90 11,71
0,10 0,34 0,34
14,91 2,95 5,85
1,49 1,00 1,99
5,37 3,61 7,16
4,49
16,15
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
269,13 7.800,00
16,15 468,00
8.069,13
484,15
43/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 05_NFPA
Equipment fire exposed:
DELUGE VALVE STATION Nº
ELEVATION
011-C-0004
TL. 107000
011-C-0005
TL. 123700
SEE NOTE
011-C-0006
TL. 109000
SEE NOTE
011-E-0022
CL. 106900
011-G-0008A/B
BP. 100300
011-G-0014B
BP. 100300
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DESCRIPCION
m
m
011-C-0004 011-E-0022 011-G-0008A/B 011-G-0014B
7,50 4,56 4,45 5,85
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
3,20 1,25 2,10 2,40
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
75,40 19,63 9,35 14,05
0,10 0,10 0,34 0,34
37,70 9,81 4,68 7,02
3,77 0,98 1,59 2,39
13,57 3,53 5,72 8,60
8,73
31,43
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
523,78 7.800,00
31,43 468,00
8.323,78
499,43
44/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 06_NFPA
DELUGE VALVE STATION Nº
Equipment fire exposed:
ELEVATION
011-G-0011B
BP. 100300
011-G-0012A/B
BP. 100300
011-D-0001
CL. 105330
011-G-0007A/B
BP. 100300
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
DESCRIPCION
m
m
011-G-0011B 011-G-0012A/B 011-D-0001 011-G-0007A/B
3,35 6,30 25,00 9,61
1,70 5,43 3,66 6,78
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
5,68 34,23 302,01 65,18
0,34 0,34 0,10 0,34
2,84 17,12 151,01 32,59
0,97 5,82 15,10 11,08
3,48 20,95 54,36 39,89
32,97
118,68
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
1.978,01 7.800,00
118,68 468,00
9.778,01
586,68
45/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 07_NFPA
Equipment fire exposed:
DELUGE VALVE STATION Nº
ELEVATION
011-G-0010A/B
BP. 100300
011-G-0005/B
BP. 100300
011-A-0005
EL. 119000
011-G-0002A
BP. 100300
EQUIPMENT HAZARD
LENGTH HEIGHT
SEE NOTE
WIDTH
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
DESCRIPCION
m
m
011-G-0010A/B 011-G-0005/B 011-G-0002A
6,08 3,21 3,68
5,63 1,85 7,53
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
34,24 5,92 27,73
0,34 0,34 0,34
17,12 2,96 13,87
5,82 1,01 4,71
20,96 3,62 16,97
11,54
41,55
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
692,53 7.800,00
41,55 468,00
8.492,53
509,55
46/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 08_NFPA
DELUGE VALVE STATION Nº
Equipment fire exposed:
ELEVATION
011-G-0002A
BP. 100300
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
DESCRIPCION
m
m
011-G-0002A
7,53
3,40
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
25,60
0,34
12,80
4,35
15,67
4,35
15,67
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
261,14 7.800,00
15,67 468,00
8.061,14
483,67
47/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 09_NFPA
DELUGE VALVE STATION Nº
Equipment fire exposed:
ELEVATION
011-A-0003
EL. 119000
SEE NOTE
011-A-0004
EL. 119000
SEE NOTE
011-G-0001A
BP. 101000
011-G-0025
BP. 100300
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
DESCRIPCION
m
m
011-G-0001A 011-G-0025
9,07 2,00
3,20 2,00
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
29,02 4,00
0,34 0,34
14,51 2,00
4,93 0,68
17,76 2,45
5,61
20,21
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
336,84 7.800,00
20,21 468,00
8.136,84
488,21
48/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 10_NFPA
DELUGE VALVE STATION Nº
Equipment fire exposed:
ELEVATION
011-D-0001
CL. 105300
011-D-0002
CL. 105300
011-G-0026B
BP. 100300
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DESCRIPCION
m
m
011-D-0001 011-D-0002 011-G-0026B
25,00 25,00 2,75
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
3,66 3,66 1,62
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
604,02 604,37 4,45
0,10 0,10 0,34
302,01 302,18 2,22
30,20 30,22 0,76
108,72 108,79 2,72
61,18
220,23
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
3.670,55 7.800,00
220,23 468,00
11.470,55
688,23
49/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 01_NFPA
DELUGE VALVE STATION Nº
Equipment fire exposed:
ELEVATION
011-D-0016
TL. 107000
011-D-0017
TL. 114000
011-F-0001
TOS. 103000
011-F-0002
TOS. 103000
011-G-0015B
BP. 100300
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DESCRIPCION
m
m
011-D-0016 011-D-0017 011-F-0001 011-F-0002 011-G-0015B
2,20 2,01 7,50 7,50 4,95
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
0,91 0,91 20,00 18,00 2,15
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
7,24 6,68 471,24 424,12 10,65
0,10 0,10 0,10 0,10 0,34
3,62 3,34 235,62 212,06 5,33
0,36 0,33 23,56 21,21 1,81
1,30 1,20 84,82 76,34 6,52
47,27
170,19
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
2.836,46 7.800,00
170,19 468,00
10.636,46
638,19
50/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 12_NFPA
DELUGE VALVE STATION Nº
Equipment fire exposed:
ELEVATION
011-F-0001
TOS. 100300
011-G-0018B
BP. 10300
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DESCRIPCION
m
m
011-F-0001 011-G-0018B
7,50 5,85
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
20,00 2,40
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
471,24 14,05
0,10 0,34
235,62 7,02
23,56 2,39
84,82 8,60
25,95
93,42
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
1.557,02 7.800,00
93,42 468,00
9.357,02
561,42
51/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 13_NFPA
DELUGE VALVE STATION Nº
Equipment fire exposed:
ELEVATION
011-C-0003
TL. 111500
SEE NOTE
011-C-0005
TL. 123700
SEE NOTE
011-C-0006
TL. 109000
SEE NOTE
011-E-0020C/D/E
CL. 105564
011-F-0001
TOS. 103000
011-G-0013A/B
BP. 100300
011-G-0014B
BP. 100300
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DESCRIPCION
m
m
011-E-0020C/D/E 011-F-0001 011-G-0013A/B 011-G-0014B
5,47 7,50 5,09 5,85
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
1,60 20,00 3,06 2,40
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
90,85 471,24 15,57 14,05
0,10 0,10 0,34 0,34
45,43 235,62 7,78 7,02
4,54 23,56 2,65 2,39
16,35 84,82 9,53 8,60
33,14
119,30
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
1.988,39 7.800,00
119,30 468,00
9.788,39
587,30
52/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 14_NFPA
Equipment fire exposed:
DELUGE VALVE STATION Nº
ELEVATION
011-C-0005
TL. 123700
011-F-0001
TOS. 103000
SEE NOTE
011-C-0006
TL. 109000
SEE NOTE
011-D-0004
CL. 118500
SEE NOTE
011-D-0015
CL. 101950
011-E-0019D/E
CL. 103150
011-E-0021
CL. 116150
011-G-0009A
BP. 100300
SEE NOTE
011-G-0005A/B
BP. 100300
011-G-0010A
BP. 100300
011-G-0013A/B
BP. 100300
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DESCRIPCION
m
m
011-F-0001 011-D-0015 011-E-0019D/E 011-G-0009A 011-G-0005A/B 011-G-0010A 011-G-0013A/B
7,50 2,80 4,28 3,86 5,05 5,63 5,09
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
20,00 1,50 1,62
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
471,24 15,67 49,29
0,10 0,10 0,10 0,34 0,34 0,34 0,34
235,62 7,83 24,64
23,56 0,78 2,46
84,82 2,82 8,87
26,81
96,51
1,70 3,21 2,08 3,06
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
1.608,58 7.800,00
96,51 468,00
9.408,58
564,51
53/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 15_NFPA
DELUGE VALVE STATION Nº
Equipment fire exposed:
ELEVATION
011-C-0005
TL. 123700
SEE NOTE
011-C-0006
TL. 109000
SEE NOTE
011-G-0009A
BP. 100300
011-G-0014A
BP. 100300
011-E-0020F
CL. 103220
011-G-0008A/B
BP. 100300
011-E-0018 C/D
CL. 105139,5
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
DESCRIPCION
m
m
011-G-0009A 011-G-0014A 011-E-0020F 011-G-0008A/B 011-E-0018 C/D
3,86 5,85 5,47 4,45 5,54
1,97 2,40 1,60 6,10 1,64
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
7,58 14,05 30,28 27,17 62,95
0,34 0,34 0,10 0,34 0,10
3,79 7,02 15,14 13,58 31,47
1,29 2,39 1,51 4,62 3,15
4,64 8,60 5,45 16,63 11,33
12,96
46,65
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
777,50 7.800,00
46,65 468,00
8.577,50
514,65
54/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 16_NFPA
DELUGE VALVE STATION Nº
Equipment fire exposed:
ELEVATION
011-D-0001
CL. 105330
011-E-0016B
CL. 103150
011-E-0018A/B
CL. 105439,5
011-E-0020A/B
CL. 103220
011-G-0011A
BP. 100300
011-G-0012A
BP. 100300
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DESCRIPCION
m
m
011-D-0001 011-E-0016B 011-E-0018A/B 011-E-0020A/B 011-G-0011A 011-G-0012A
25,00 6,75 5,54 5,47 3,35 5,43
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
3,66 1,61 1,64 1,60 1,70 2,30
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
302,01 37,04 62,95 60,57 5,68 12,50
0,10 0,10 0,10 0,10 0,34 0,34
151,01 18,52 31,47 30,28 2,84 6,25
15,10 1,85 3,15 3,03 0,97 2,12
54,36 6,67 11,33 10,90 3,48 7,65
26,22
94,39
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
1.573,15 7.800,00
94,39 468,00
9.373,15
562,39
55/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 17_NFPA
DELUGE VALVE STATION Nº
Equipment fire exposed:
ELEVATION
011-D-0003
CL. 109000
SEE NOTE
011-E-0004B
CL. 116750
SEE NOTE
011-E-0016B
CL. 103150
011-E-0018A/B
CL. 105439,5
011-G-0008A/B
BP. 100300
011-G-0010A/B
BP. 100300
011-G-0012A/B
BP. 100300
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DESCRIPCION
m
m
011-E-0016B 011-E-0018A/B 011-G-0008A/B 011-G-0010A/B 011-G-0012A/B
6,75 5,54 4,45 5,63 5,34
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
1,61 1,64 6,10 6,08 6,30
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
37,04 62,95 27,17 34,24 33,64
0,10 0,10 0,34 0,34 0,34
18,52 31,47 13,58 17,12 16,82
1,85 3,15 4,62 5,82 5,72
6,67 11,33 16,63 20,96 20,59
21,16
76,17
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
1.269,53 7.800,00
76,17 468,00
9.069,53
544,17
56/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 18_NFPA
Equipment fire exposed:
DELUGE VALVE STATION Nº
ELEVATION
011-E-0019C
CL. 103150
011-G-0010B
BP. 100300
011-G-0005B
BP. 100300
011-E-0016A
CL. 103150
011-E-0015A/B
CL. 105314,5
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DESCRIPCION
m
m
011-E-0019C 011-G-0010B 011-G-0005B 011-E-0016A 011-E-0015A/B
4,28 5,63 3,21 6,75 6,85
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
1,62 2,08 1,85 1,61 1,47
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
24,64 11,71 5,92 37,04 67,75
0,10 0,34 0,34 0,10 0,10
12,32 5,85 2,96 18,52 33,87
1,23 1,99 1,01 1,85 3,39
4,44 7,16 3,62 6,67 12,19
9,47
34,08
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
568,07 7.800,00
34,08 468,00
8.368,07
502,08
57/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 19_NFPA
DELUGE VALVE STATION Nº
Equipment fire exposed:
ELEVATION
011-D-0003
CL. 109000
011-E-0017B
CL. 102900
011-E-0018C/D
CL. 105439,5
SEE NOTE
011-G-0008B
BP. 100300
011-E-0004B
CL. 116750
SEE NOTE
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DESCRIPCION
m
m
011-E-0017B 011-E-0018C/D 011-G-0008B
5,72 5,54 4,45
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
1,12 1,64 2,10
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
21,40 62,95 9,35
0,10 0,10 0,34
10,70 31,47 4,68
1,07 3,15 1,59
3,85 11,33 5,72
5,81
20,91
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
348,46 7.800,00
20,91 468,00
8.148,46
488,91
58/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 20_NFPA
Equipment fire exposed:
DELUGE VALVE STATION Nº
ELEVATION
011-E-0017A
CL. 102900
011-E-0018A/B
CL. 105439,5
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DESCRIPCION
m
m
011-E-0017A 011-E-0018A/B
5,72 5,54
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
1,12 1,64
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
21,40 62,95
0,10 0,10
10,70 31,47
1,07 3,15
3,85 11,33
4,22
15,18
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
253,06 7.800,00
15,18 468,00
8.053,06
483,18
59/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 21_NFPA
Equipment fire exposed:
DELUGE VALVE STATION Nº
ELEVATION
011-E-0017B
CL. 102900
011-E-0018C/D
CL. 105439,5
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DESCRIPCION
m
m
011-E-0017B 011-E-0018C/D
5,72 5,54
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
1,12 1,64
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
42,81 62,95
0,10 0,10
21,40 31,47
2,14 3,15
7,71 11,33
5,29
19,04
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
317,27 7.800,00
19,04 468,00
8.117,27
487,04
60/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1
DELUGE VALVE STATION Nº
Equipment fire exposed:
ELEVATION
011-D-0001
CL.105330
011-D-0002
CL.105330
011-E-0017B
CL. 102900
011-E-0018C/D
CL. 105439,5
011-G-0008B
BP. 100300
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DESCRIPCION
m
m
011-D-0001 011-D-0002 011-E-0017B 011-E-0018C/D 011-G-0008B
25,00 25,00 5,72 5,54 4,45
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
3,66 3,66 1,12 1,64 2,10
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
302,01 302,01 21,40 62,95 9,35
0,10 0,10 0,10 0,10 0,34
151,01 151,01 10,70 31,47 4,68
15,10 15,10 1,07 3,15 1,59
54,36 54,36 3,85 11,33 5,72
36,01
129,63
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
2.160,53 7.800,00
129,63 468,00
9.960,53
597,63
61/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 23_NFPA
DELUGE VALVE STATION Nº
Equipment fire exposed:
ELEVATION
011-D-0001
CL. 105330
011-D-0002
CL. 105330
011-D-0018
CL. 108800
011-E-0001
CL. 102950
011-E-0006
CL. 103275
SEE NOTE
011-E-0023
CL. 102180
011-G-0001A/B
BP. 101000
011-G-0002A/B
BP. 101000
011-G-0026A/B
BP. 100300
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DESCRIPCION
m
m
011-D-0001 011-D-0002 011-E-0001 011-E-0006 011-E-0023 011-G-0001A/B 011-G-0002A/B 011-G-0026A/B
25,00 25,00 5,55 6,73 7,05 9,07 7,53 2,75
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
3,66 3,66 1,32 1,35 1,21 3,20 3,40 4,52
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
302,01 302,01 24,93 30,53 28,39 58,05 51,20 12,43
0,10 0,10 0,10 0,10 0,10 0,34 0,34 0,34
151,01 151,01 12,47 15,26 14,20 29,02 25,60 6,21
15,10 15,10 1,25 1,53 1,42 9,87 8,70 2,11
54,36 54,36 4,49 5,49 5,11 35,53 31,34 7,60
55,08
198,28
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
3.304,73 7.800,00
198,28 468,00
11.104,73
666,28
62/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 24_NFPA
DELUGE VALVE STATION Nº
Equipment fire exposed:
ELEVATION
011-C-0003
TL. 11500
SEE NOTE
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
TOTAL SURFACE
DENSITY
50% OF SURFACE AREA
DESCRIPCION
m
m
m
m2
m2
m2
L/m2s
m2
REQUIRED WATER DEMAND
L/s
m3/hr
0,34 0,10
TOTAL SYSTEM
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
7.800,00
468,00
7.800,00
468,00
63/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 25_NFPA
Equipment fire exposed:
DELUGE VALVE STATION Nº
ELEVATION
011-C-0003
TL. 115000
011-F-0001
TOS. 103000
SEE NOTE
011-F-0002
TOS. 103000
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DESCRIPCION
m
m
011-F-0001 011-F-0002
7,50 7,50
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
20,00 18,00
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
471,24 424,12
0,10 0,10
235,62 212,06
23,56 21,21
84,82 76,34
44,77
161,16
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
2.686,06 7.800,00
161,16 468,00
10.486,06
629,16
64/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 03
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801 CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 26_NFPA
Equipment fire exposed:
DELUGE VALVE STATION Nº
ELEVATION
011-D-0015
CL. 101950
011-F-0002
TOS. 103000
011-G-0017B
BP, 100300
011-G-0018B
BP. 100300
EQUIPMENT HAZARD
LENGTH HEIGHT
WIDTH
DESCRIPCION
m
m
011-D-0015 011-F-0002 011-G-0017B 011-G-0018B
2,80 7,50 7,53 5,85
DIAMETER
BOTTON SURFACE
LATERAL SURFACE
m
m2
m2
1,50 18,00 3,30 2,40
50% OF SURFACE AREA
TOTAL SURFACE
DENSITY
m2
L/m2s
m2
L/s
m3/hr
15,67 424,12 24,85 14,05
0,10 0,10 0,34 0,34
7,83 212,06 12,42 7,02
0,78 21,21 4,22 2,39
2,82 76,34 15,21 8,60
28,60
102,97
TOTAL SYSTEM
REQUIRED WATER DEMAND
FIREWATER DEMANDS REQUIRED MONITORS
AREA
QUANTY:
UNIT FLOW
TOTAL REQUIRED DELUGE SYSTEMS AREA
QUANTY: QUANTY:
TOTAL TO BE INSTALLED
SA-JER-DS101-TRJR-675801
UNIT 101 -LOW PRESSURE HYDRODESULPHURISATION- Fire Water Demand IFC
7.800,00
468,00
7.800,00
468,00
1.716,12 7.800,00
102,97 468,00
9.516,12
570,97
65/66
JUBAIL EXPORT REFINERY PROJECT
Rev. No. 01
PROJECT No. 02020 DOC. No. SA-JER-DS011-TRJR-675801
TR Jubail
CRUDE DISTILLATION UNIT TRAIN 1 FIRE WATER DEMAND AFC
4. CONCLUSION The fire water demand on CRUDE DISTILLATION UNIT TRAIN 1, has been evaluated on the basis of the maximum fire water flow need for the worst fire scenario associated to the risk area. The worst fire scenario has been evaluated considering the fire water flow required for the fire fighting measures needs for extinguishing the fire pool and cooling the involved and adjacent equipments. The scenario 10 is the worst scenario. The fire water flow needs for the Scenario 10 is 688,23 m3/h. CRUDE DISTILLATION UNIT TRAIN 1 SCENARIO 01_NFPA SCENARIO 02_NFPA SCENARIO 03_NFPA SCENARIO 04_NFPA SCENARIO 05_NFPA SCENARIO 06_NFPA SCENARIO 07_NFPA SCENARIO 08_NFPA SCENARIO 09_NFPA SCENARIO 10_NFPA SCENARIO 11_NFPA SCENARIO 12_NFPA SCENARIO 13_NFPA SCENARIO 14_NFPA SCENARIO 15_NFPA SCENARIO 16_NFPA SCENARIO 17_NFPA SCENARIO 18_NFPA SCENARIO 19_NFPA SCENARIO 20_NFPA SCENARIO 21_NFPA SCENARIO 22_NFPA SCENARIO 23_NFPA SCENARIO 24_NFPA SCENARIO 25_NFPA SCENARIO 26_NFPA
TOTAL FLOW L/min 8.148,79 8.295,46 9.029,86 8.069,13 8.323,78 9.778,01 8.492,53 8.061,14 8.136,84 11.470,55 10.636,46 9.357,02 9.788,39 9.408,58 8.577,50 9.373,15 9.069,53 8.368,07 8.148,46 8.053,06 8.117,27 9.960,53 11.104,73 7.800,00 800 00 10.486,06 9.516,12
m3/h 488,93 497,73 541,79 484,15 499,43 586,68 509,55 483,67 488,21 688,23 638,19 561,42 587,30 564,51 514,65 562,39 544,17 502,08 488,91 483,18 487,04 597,63 666,28 468,00 68 00 629,16 570,97
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 24.
CCTV EQUIPMENT LAYOUT, CABLE ROUTING & GROUNDING POINTS Document Number
Description
SA-JER-DS011-TRJR-345610
CCTV EQUIPMENT LAYOUT, CABLE ROUTING & GROUNDING POINTS
Rev. 02
ORIGINAL SIGNED IN PROJECT FILE
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 25.
UNIT 011 CCTV EQUIPMENT LAYOUT & CABLE ROUTING Document Number
Description
SA-JER-DS091-TRJR-345613
UNIT 011 CCTV EQUIPMENT LAYOUT & CABLE ROUTING
Rev. 02
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 26.
PIB 05.SS106 AND US05 SCS OUTLETS LAYOUT AND CABLE ROUTING
Document Number
Description
SA-JER-DS011-TRJR-345604
PIB 05.SS106 AND US05 SCS OUTLETS LAYOUT AND CABLE ROUTING
Rev. 05
ORIGINAL SIGNED IN PROJECT FILE
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 27.
OUTDOOR LS, FB & P/LS CABLE ROUTING & GROUNDING POINTS
Document Number
Description
SA-JER-DS011-TRJR-345611
OUTDOOR LS, FB & P/LS CABLE ROUTING & GROUNDING POINTS
Rev. 02
ORIGINAL SIGNED IN PROJECT FILE
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 28.
PIB 05 INDOOR LS & P/LS LAYOUT AND CABLE ROUTING Document Number
Description
SA-JER-DS091-TRJR-345606
PIB 05 INDOOR LS & P/LS LAYOUT AND CABLE ROUTING
Rev. 03
ORIGINAL SIGNED IN PROJECT FILE
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 29.
FLARE LOAD SUMMARY Document Number
Description
SA-JER-DS011-TRJR-670005
FLARE LOAD SUMMARY
Rev. 03
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 30.
CHEMICAL SUMMARY Document Number
Description
SA-JER-DS011-TRJR-670003
CHEMICALS CONSUMPTION SUMMARY CDU/VDU UNIT
Rev. 04
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 31.
CDU/VDU PREPARATION FOR START UP Document Number
Description
SA-JER-DS011-TRJR-400001
CDU/VDU PREPARATION FOR START UP
Rev. 01
ORIGINAL SIGNED IN PROJECT FILE INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 1 of 39
DOCUMENT: SA‐JER‐DS011‐TRJR‐400001
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Note: This document does not replace the corresponding “Operating Procedure” or “OPERGUID” which will be developed by SATORP. REVISION CONTROL REV. 00 01
DATE 07‐APR‐2011 21‐OCT‐2011
DESCRIPTION ISSUE FOR REVIEW APPROVED FOR CONSTRUCTION
CHECKED BY
PREPARED BY Miguel A. Castro
APPROVED BY Juan Lechuga
José Luis Roldan
DISCIPLINE CODE PRO Document Class: 2
DOCUMENT TYPE MAN
UNIT 011
SYSTEM
Legend
o ◊
Action Verification Safety Action
B – Board Operator F– Field Operator S – Shift Supervisor
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 2 of 39
LEVEL I LOGIC DIAGRAM
INITIAL STATE System to be prepared for Start‐up
100 PURGING OF FEED SECTION
STABLE STATE S1 Feed section purged
200
PURGING OF PREFLASH SECTION STABLE STATE S2 Preflash section purged
300
400
500
PURGING OF ATMOSPHERIC DISTILLATION SECTION STABLE STATE S3 Atmospheric distillation section purged
PURGING OF VACUUM DISTILLATION SECTION STABLE STATE S4 Vacuum distillation section purged
PURGING OF AMINE SECTION STABLE STATE S5 Amine section purged
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 3 of 39
600
700
PURGING OF SLOP COOLING SYSTEM STABLE STATE S6 Slop cooling system purged
PRESSURE UNIT USING FUEL GAS FINAL STATE CDU / VDU UNIT purged and pressurized
Note: The start up of the unit is described in the intermediate procedure “CDU/VDU Start‐up” 011‐IP‐ 0002. Note: Steps 100, 200, 300, 400, 500 and 600 could be performed at the same time or independently.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 4 of 39
LEVEL I SUMMARY LOGIC DIAGRAM ........................................................................................................................................... 2 SUMMARY .................................................................................................................................................... 4 INITIAL STATE SHEET .................................................................................................................................... 5 100 PURGING OF FEED SECTION ...................................................................................................... 7 110 PURGING AND PRESSURE OF DESALTING WATER SECTION ...................................................... 8 120 PURGING AND PRESSURE OF DESALTERS SECTION ................................................................... 9 STABLE STATE 1 SHEET ............................................................................................................................... 11 200 PURGING OF PREFLASH SECTION ............................................................................................ 12 210 PURGING OF PREFLASH OVERHEAD SECTION ......................................................................... 12 220 PURGING OF PREFLASH BOTTOM SECTION ............................................................................ 13 230 PURGING OF ATMOSPHERIC HEATER SECTION ....................................................................... 13 STABLE STATE 2 SHEET ............................................................................................................................... 15 300 PURGING OF ATMOSPHERIC DISTILLATION SECTION .............................................................. 16 310 PURGING OF OVERHEAD SECTION .......................................................................................... 16 320 PURGING OF KEROSENE PUMPAROUND AND PRODUCT SECTION ......................................... 17 330 PURGING OF LIGHT ATMOSPHERIC GASOIL PUMPAROUND AND PRODUCT SECTION ........... 17 340 PURGING OF HEAVY ATMOSPHERIC GASOIL PUMPAROUND AND PRODUCT SECTION ......... 18 350 PURGING OF ATMOSPHERIC RESIDUE SECTION ...................................................................... 19 STABLE STATE 3 SHEET ............................................................................................................................... 21 400 PURGING OF VACUUM DISTILLATION SECTION ...................................................................... 22 410 PURGING OF VACUUM HEATER SECTION ............................................................................... 22 420 PURGING OF VDU OFFGAS COMPRESSOR............................................................................... 22 430 PURGING OF OVERHEAD SECTION – VACUUM PACKAGE AND OFFGAS SYSTEM ................... 23 440 PURGING OF LIGHT VACUUM GASOIL PUMPAROUND AND PRODUCT SECTION ................... 24 450 PURGING OF MEDIUM AND HEAVY VACUUM GASOIL PUMPAROUND AND PRODUCT SECTION .............................................................................................................................................. 24 460 PURGING OF VACUUM RESIDUE SECTION .............................................................................. 25 STABLE STATE 4 SHEET ............................................................................................................................... 27 500 PURGING OF AMINE SECTION ................................................................................................. 28 STABLE STATE 5 SHEET ............................................................................................................................... 30 600 PURGING OF SLOP COOLING SYSTEM ..................................................................................... 31 STABLE STATE 6 SHEET ............................................................................................................................... 32 700 PRESSURE UNIT USING FUEL GAS ............................................................................................ 34 710 PRESSURE THE FEED AND PREFLASH SECTION ........................................................................ 34 720 PRESSURE THE ATMOSPHERIC DISTILLATION SECTION ........................................................... 34 730 PRESSURE THE VACUUM DISTILLATION SECTION ................................................................... 34 FINAL STATE SHEET ..................................................................................................................................... 36
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 5 of 39
LEVEL II INITIAL STATE SHEET INITIAL STATE System to be prepared for start‐up DESCRIPTION o Tightness test of the unit has been performed for each section through a dedicated procedure developed by Operation Group. Note: Vacuum Hold Test of the Vacuum system applied to pipes and equipment involved in C‐0003 vacuum tower, Vacuum production equipment and sour water evacuation system. The Vacuum Hold Test identifies leaks under negative pressure, after the unit plant has been cleaned and leak under positive pressure Tests has been carried out. Note: The Vacuum test can be done after the positive pressure leak test or could be performed during the steam purge of the unit. In case be performed after the positive pressure leak test: ‐ Positive pressure leak test (using instrument air) is performed as previous step to Vacuum test. The system is pressurized up to 0.5 barg for check leaks at the flanged connections and then to 1.5 barg in order to verify the integrity of all flanged joints. ‐ After the positive leak test, the pressure of the system is reduced to negative levels by means of the steam ejectors. Then, the system is held under the vacuum pressure for four (4) hours and the system will be checked for leakage. o o o o o o o o o o o o
Hydrostatic test has been done. System has been cleaned of debris and scale. Vessel internals (trays, demisters, pads, weirs, baffles, vortex breakers, instrument taps, etc.) are installed correctly, gasketed and any internal flow tests and measurements are carried out. Air cooler tube fins have been inspected and checked for cleanliness. Equipment isolation blinds are removed or move to the open position for start‐up purposes. Rotary equipment have been inspected, tested and energized. Strainers at pump suction line are cleaned, installed, orientated correctly and pressure indicators are fitted. All instruments, and control systems are ready for service. Analyzers are ready for service but isolated from the process system. Sampling connections are closed. Safety relief valves have been tested and installed. Isolation valves are in open position. Heat tracing shall be established. All the utility, drains and process blinds are open. Only the Process Battery Limit blinds shall be closed.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 6 of 39
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1 Note: Flare System and Closed Drain System shall be inerted with nitrogen until the oxygen level is lower than 0.5% vol. previous to purge the entire unit. Both systems are slightly pressurized with nitrogen. Specific procedures are developed for these systems. Refer to: 011‐IP‐0015 (Steps 200 and 300)/0017 (Step 220, previous steps to closed drain alignment to Flare) respectively. UTILITIES o All utilities shall be available, but special attention shall be taken to: o LP Steam ready to use (For steps 100, 200, 300, 400 and 600). o MP Steam ready to use (For steps 200 and 400). o Nitrogen ready to use (For steps 100, 400 and 500). o Fuel gas ready to use (For step 700).
Note: At this step, Fuel gas systems shall be inerted with nitrogen until the oxygen level is lower than 0.5% vol. Refer to 011‐IP‐0015 (Step 200). Fuel gas shall be admitted after the purging has been completely done in all entire unit. o o
Oily water system in service. Closed drain and Amine drain in service. At this step, the amine drain system shall be inerted with nitrogen.
Note: Refer to dedicated intermediate procedure for the gas in / start‐up of the utilities system, which are out of the scope of this procedure. Note: At this step, the status of blinds is the following: 1) Process Battery Limit blinds shall be closed, but the blinds inside the unit are open. 2) All Utilities Battery limit blinds shall be open. Flare system under slight over pressure of nitrogen turn clear the blind in the unit relief header for connection to the refinery. This must be done before the introduction of any liquid or gaseous. MATERIAL o Portable oxygen meters. SAFETY ◊ Extinguishers are in position and available. ◊ Steam hoses and monitor hoses are available. ◊ Fire water system, safety showers, gas sensors are available.
Note: Operator shall check that there is no gap between the initial state described above and the current situation of the system. If any gap is identified, operator shall take the necessary actions to close this gap before continuing with the next step.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 7 of 39
LEVEL II ACTIONS 100
PURGING OF FEED SECTION
Note: The feed section comprises the following pieces of equipment: G‐0001 A/B, cold crude preheat train in series E‐0001, E‐0002, E‐0003 A/D, E‐0004 A/B, E‐0005, E‐0006, E‐0007 A‐B/C‐D, E‐0008 and E‐ 0009 A/B, D‐0001&0002 are by‐passing; G‐0002 A/B, hot crude preheat train E‐0010A/B, E‐0011A/B, E‐0012A/B, E‐0013, E‐0014A‐F and the inlet line to preflash column C‐0001. Note: Equipment suitable for steam out have not been designed for full vacuum conditions but for half vacuum. Attention shall be paid to that Administrative Controls which shall indicate that no steam out of an equipment can be done if the equipment is isolated; before starting the steam out of an equipment the vent (to atmosphere) shall be opened.
o
(S/F) Ensure that the feed section is isolated from other sections (feed lines from battery limit up to preflash column C‐0001. Check that the following items are closed and proceed to close if they are not in the right position: ‐ (S/F) Verify block valves and blinds at battery limit associated to ZV‐0046 and ZV‐0120 (Crude feed and Slop feed from storage). ‐ (B/F) ZV‐0087 and ZV‐0088 (Desalters D‐0001 and D‐0002 inlets). ‐ (F) Block valves on outlet line of desalter D‐0001, 18”‐CRD‐011006002. ‐ (F) Block valves on outlet line of desalter D‐0002, 18”‐CRD‐011007002. ‐ (F) Block valves on Desalting water injection lines 4”PRW‐01142005, 6”‐BRN‐ 011007002, and 6”‐PRW‐011042006. ‐ (S/F) Block valves and blind on Wild naphtha injection line, 3”‐NPH‐011098002. ‐ (B) ZV‐0002 (Topped crude C‐0001 bottom outlet line). ‐ (F) Block valves on line MP stripping steam inlet line to C‐0001, 8”‐MPS‐011011002. ‐ (S/F) Block valves and blinds on Preflash overhead line to E‐0004 A/B, 16”‐NPH‐ 011011001. ‐ (S/F) Block valves and blinds on Demulsifier injection lines 1”‐CHP‐011053001, 1”‐CHP‐ 011053002 and 1”‐CHP‐011053003. ‐ (S/F) Block valves and blinds on Corrosion inhibitor injection line, 1”‐INH‐011054001. ‐ (S/F) Block valves and blinds on Neutralizing agent injection line, 1”‐CHP‐011054001. (B) Close control valves FV‐0008 (G‐0004 minimum flow) and FV‐0009 (Preflash reflux). (F) Close FV‐0008 and FV‐009 bypass valves. (F) Verify that block valves for all utilities and any vent to the flare connections are closed in the section. (B) Open ZV‐0046 (Crude feed from storage Unit 561). (B) Open ZV‐0120 (Slop feed from storage Unit 681). (S/F) Open block valves and blinds located on D‐0001 and D‐0002 bypass lines 16”‐CRD‐ 011006001 and 16”‐CRD‐011007006 respectively. (B/F) Ensure the entire feed section, from isolation blinds at battery limits to C‐0001, is open; including all the block valves, control valves and on‐off valves within the section. (F) Open all vents and drains included in the feed section. Open C‐0001 top vent. (F) Open UC valves and steam out the entire section using LP steam for at least 12 hours.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 8 of 39
◊
(F) Place a flexible LP steam hose connection to UC valve at C‐0001 bottom and proceed with the steaming. (F) Verify that oxygen content is less than 0.5% vol. (F) Limit drain valves to a 50%, once vapor starts coming out from all drain valves. (F) Limit vent valves to a 50%, once vapor starts coming out from all vent valves. (F) Leave C‐0001 top vent totally open.
110 PURGING AND PRESSURE OF DESALTING WATER SECTION Note: The section comprises the following pieces of equipment: D‐0007, G‐0021 A/B, E‐0024, E‐0032 A/B and the inlet lines to cold crude preheat train and D‐0001&D‐0002.
o
(F) Ensure that the desalting water section is isolated from other sections (Phenolic and Non‐ phenolic stripped water from battery limit up to crude preheat and desalter injection points). Check that the following items are closed and proceed to close if they are not in the right position: ‐ (S/F) Block valve and blind at battery limit on Non phenolic stripped water from Unit 213. ‐ (S/F) Block valve and blind at battery limit on Phenolic stripped water from Unit 211. ‐ (F) Block valves on desalting water injection lines, 4”‐PRW‐01142005 and 6”‐PRW‐ 011042006. (F) Verify that block valves for all utilities and any vent to the flare connections are closed in the section. (F) Ensure that PZV‐0049&0050 are available. (F) Close all vents and drains included in the desalting water section. (B) Close control valves FV‐0059 A (BFW supply) and its bypass. (F) Check that PV‐0311A (LP nitrogen), PV‐0311B (D‐0007 vent to flare) and its bypasses are closed. (B) Commission Pressure Control valves PC‐0311. Set pressure control PV‐311 A and PV‐0311 B at 0.5 barg in slip range mode. Check the opening of control valve PV‐0311 A (L.P. nitrogen supply). (B/F) Ensure the entire desalting water section, from Phenolic and Non‐phenolic stripped water battery limit to crude preheat and desalter injection points, is open; including all the block valves, control valves and on‐off valves within the section (F) Increase gradually the nitrogen flow through line 2”‐LPN‐011043301 located on D‐0007 blanketing and increase the pressure in D‐0007.
Note: It could also be used others connections within the desalting water system to pressurize it with nitrogen. (F) Pressure the section up to 1.0 barg. Note: Among others pressure indicators around the system, the pressure could be checked on PI‐0310 on D‐0007 top.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 9 of 39
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1 Note: Care must be taken as the design pressure of this section is lower than nitrogen supply normal pressure. Hence, a continuous follow‐up of the system pressure shall be done, controlling the N2 entrance to the system through the manual valve available in the N2 injection line
(F) Vent directly to atmosphere through vessel top and line vents. Vents should be opened and a good plume of gas established. (F) Drain any condensate as rapidly as it forms through drains on equipment and low points in lines. (F) Pressure up to 1 barg and de‐pressure several times until the oxygen content is lower than 0.5% vol. Usually three cycles are required to reach the desired value. (F) Close all drains when no liquid comes out of the drains. (F) Close vents and stop the nitrogen supply when the system has been thoroughly purged. (F) Fill the section with nitrogen to maintain a slight positive pressure, 0.3 barg.
Note: Under no circumstances should nitrogen/air mixture be vented into the flare system as it could lead to explosive atmospheres within the flare system. Note: Non phenolic stripped water line exists only for unit 011 and not for unit 012. 120 PURGING AND PRESSURE OF DESALTERS SECTION
Note: The section comprises the following pieces of equipment: D‐0001&D‐0002, G‐0024 A/B, E‐0032 (Brine side), A‐0006, and E‐0036.
o
(F) Ensure that the Desalters D‐0001 and D‐0002 section is isolated (Desalters up to brine battery limit). Check that the following items are closed and proceed to close if they are not in the right position: ‐ (B) ZV‐0087 and ZV‐0088 (Desalter D‐0001 and D‐0002 inlets). ‐ (F) Block valves on outlet line of desalter D‐0001, 18”‐CRD‐011006002. ‐ (F) Block valves on outlet line of desalter D‐0002, 18”‐CRD‐011007002. ‐ (F) Block valves on Desalting water injection line 6”‐BRN‐011007002. ‐ (S/F) Block valve and blind at battery Brine to WWT Unit 651. (F) Verify that block valves for all utilities and any vent to flare connections are closed in this section. (F) Ensure that PZV‐0001/0002/0003 and 0004 are available. (F) Close all vents and drains included in the desalters section. (F) Open globe and gate valves on Mud wash water to D‐0001 and D‐0002 on line 2”‐BRN‐ 011007011. (B/F) Ensure the entire desalters section, from D‐0001 and D‐0002 to brine battery limit, is open; including all the block valves, control valves and on‐off valves within the section. (F) Increase gradually the nitrogen flow by flexible hose to the utility connection on line 3”‐BRN‐ 011006301 , 3”‐BRN‐011006302 , 3”‐BRN‐011007301 and 3”‐BRN‐011007302 and increase the pressure in D‐0001 and D‐0002.
Note: It could also be used others connections within the Desalters section to pressurize the system with nitrogen.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 10 of 39
(F) Pressure the section up to 1.0 barg. Note: Among others pressure indicators around the system, the pressure could be checked on PI‐0373 D and PI‐0450 D on Desalters top
(F) Vent directly to atmosphere through desalters top vents and line vents. Vents should be opened and a good plume of gas established.
Note: Care must be taken as the design pressure of this section is lower than nitrogen supply normal pressure. Hence, a continuous follow‐up of the system pressure shall be done, controlling the N2 entrance to the system through the manual valve available in the N2 injection line
(F) Drain any condensate as rapidly as it forms through drains on equipment and low points in the lines. (F) Pressure up to 1 barg and de‐pressure several times until the oxygen content is lower than 0.5% vol. Usually three cycles are required to reach the desired value. (F) Close all drains when no liquid comes out of the drains. (F) Close vents and stop the nitrogen supply when the system has been thoroughly purged. (F) Fill the section with nitrogen to maintain a slight positive pressure, 0.3 barg.
Note: Under no circumstances should nitrogen/air mixture be vented into the flare system as it could lead to explosive atmospheres within the flare system.
STABLE STATE S1 Feed section purged
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 11 of 39
LEVEL II STABLE STATE 1 SHEET STABLE STATE S1 Feed section purged DESCRIPTION o Feed section oxygen content is less than 0.5 %vol. o Steam is being continuously injected in the Feed section and C‐0001 top vent totally open. Shutoff of steam supply and pressurization with fuel gas is performed in step 700. o Desalting water system oxygen content is less than 0.5 %vol. o Desalters section oxygen content is less than 0.5 %vol. o Positive nitrogen pressure (0.3 barg) is maintained in Desalting water and Desalters sections. UTILITIES o LP steam available. o MP steam available. MATERIAL o Portable oxygen meters. SAFETY ◊ Extinguishers are in position and available. ◊ Steam hoses are available. ◊ Monitor hoses are available. ◊ Safety showers are available.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 12 of 39
LEVEL II ACTIONS 200
PURGING OF PREFLASH SECTION
Note: Steps 210, 220 and 230 could be performed at the same time or independently. 210 PURGING OF PREFLASH OVERHEAD SECTION Note: The section comprises the following pieces of equipment: C‐0001, E‐0004 A/B (shell side), D‐ 0003, G‐0003 A/B, A‐0002 A/F, E‐0021 and D‐0005. Note: Equipment suitable for steam out have not been designed for full vacuum conditions but for half vacuum. Attention shall be paid to that Administrative Controls which shall indicate that no steam out of an equipment can be done if the equipment is isolated; before starting the steam out of an equipment the vent (to atmosphere) shall be opened.
o ◊
(F) Ensure that the Preflash overhead section is Isolated from other sections (lines from preflash column C‐0001 overhead up to Naphtha battery limit). Check that the following items are closed and proceed to close if they are not in the right position: ‐ (S/F) Verify block valves and blind on Corrosion inhibitor injection line, 1”‐INH‐ 011054001. ‐ (S/F) Verify block valves and blind on Neutralizing agent injection line, 1”‐CHP‐ 011054001. ‐ (S/F) Verify block valve and blind at battery limit on Naphtha product to NHDT Unit 111. ‐ (F) Block valve on Naphtha line from G‐0005, 6”‐NPH‐011019003. (B) Close control valves PV‐0038 A (D‐0005 blanketing) and PV‐0038 B (D‐0005 offgas). (F) Close PV‐0038 A and PV‐0038 bypass valves. (F) Ensure that PZV´s on C‐0001 column, D‐0003 and D‐0005 are available. (F) Verify that block valves for all utilities and any vent to the flare connections are closed in the section. (F) Open the appropriate valves on the start‐up lines or intermittent uses lines: ‐ Naphtha filling line to D‐0003: globe and gate valves on line 4”‐NPH‐011021006. ‐ Naphtha filling line to D‐0004: globe and gate valves on line 4”‐NPH‐011021003. (S/F) Open block valves and blind on Preflash overhead line to E‐0004 A/B, 16”‐NPH‐ 011011001. (B) Open control valve FV‐0009 (Preflash reflux). (F) Open FV‐0009 bypass valve. (B/F) Ensure the entire preflash overhead section, C‐0001 overhead to Naphtha battery limit, is open; including all the block valves, control valves and on‐off valves within the section. (F) Open all vents and drains included in the overhead section. Open C‐0001, D‐0003, and D‐ 0005 top vents. (F) Open UC valves and steam out the entire section using LP steam for at least 12 hours. (F) Verify that oxygen content is less than 0.5% vol. (F) Limit drain valves to a 50%, once vapor starts coming out from all drain valves.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 13 of 39
(F) Limit vent valves to a 50%, once vapor starts coming out from all vent valves. (F) Leave C‐0001 top vent totally open. 220 PURGING OF PREFLASH BOTTOM SECTION Note: The preflash bottom section comprises the following pieces of equipment: G‐0004 A/B, hot crude preheat train E‐0015A/B, E‐0016A/B, E‐0017A/B, E‐0018A‐B/C‐D, E‐0019A‐B/C‐D, E‐0020A‐B/C‐ D and the inlet line control flow valves to crude heater F‐0001. Note: Equipment suitable for steam out have not been designed for full vacuum conditions but for half vacuum. Attention shall be paid to that Administrative Controls which shall indicate that no steam out of an equipment can be done if the equipment is isolated; before starting the steam out of an equipment the vent (to atmosphere) shall be opened. o o ◊
(B/F) Ensure that the preflash bottom section is isolated (lines from preflash column C‐0001 up to Crude heater F‐0001). Close control valves FV‐0015 A/B/C/D/E/F/G/H (Topped crude to F‐ 0001). (F) Close FV‐0015 A/B/C/D/E/F/G/H bypass valve. (F) Close all utilities and flare connections in the section. (B) Open ZV‐0002 (Topped crude C‐0001 bottom outlet line). (B) Open control valve FV‐0008 (G‐0004 minimum flow). (F) Open FV‐0008 bypass valve. (B/F) Ensure the entire presflash bottom section, C‐0001 bottom outlet to Crude heater F‐0001, is open; including all the block valves, control valves and on‐off valves within the section. (F) Line‐up the pump G‐0004 A/B through the individual suction/discharge valves. It will be purged with steam. (F) Open all vents and drains included in the preflash bottom section. Open C‐0001 top vent. (F) Open UC valves and steam out the entire section using LP steam for at least 12 hours. (F) Verify that oxygen content is less than 0.5% vol. (F) Limit drain valves to a 50%, once vapor starts coming out from all drain valves. (F) Limit vent valves to a 50%, once vapor starts coming out from all vent valves. (F) Leave C‐0001 top vent totally open.
230 PURGING OF ATMOSPHERIC HEATER SECTION Note: The Atmospheric Heater section comprises: Lines from control valves inlet passes to crude heater F‐0001, Heater F‐0001 and the Atmospheric Column C‐0002. Note: Equipment suitable for steam out have not been designed for full vacuum conditions but for half vacuum. Attention shall be paid to that Administrative Controls which shall indicate that no steam out of an equipment can be done if the equipment is isolated; before starting the steam out of an equipment the vent (to atmosphere) shall be opened.
(B/F) Ensure that the atmospheric heater section is isolated from other sections (lines from control valves inlet passes to F‐0001 up to C‐0002). Check that the following items are closed and proceed to close if they are not in the right position:
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 14 of 39
‐
o ◊
(S/F) Block valves and blind on Corrosion inhibitor injection lines, 3”‐NPH‐011019008 and 1”‐INH‐011054002. ‐ (S/F) Block valves and blind on Neutralizing agent injection line, 1”‐CHP‐011054002. ‐ (B) ZV‐0122 and ZV‐0123 (Nitrogen injection line). ‐ (S/F) Block valves and blinds on CDU overhead line to E‐0003 A/B/C/D, 28”‐NPH‐ 011018001. ‐ (B) ZV‐0077 (Kerosene drawoff tray Nº 44). ‐ (B) ZV‐0078 (LAGO drawoff tray Nº30). ‐ (B) ZV‐0079 (HAGO drawoff tray Nº15). ‐ (B) ZV‐0006 (Atmospheric residue bottom outlet line). ‐ (S/F) Block valves and blind on Wild naphtha injection line, 3”‐NPH‐011098001. ‐ (S/F) Block valve on stripping steam from F‐0001, 18”‐LPS‐011018001. Close the following control valves: ‐ (B) FV‐0019 (CDU Reflux). ‐ (B) FV‐0003 (Kerosene Pumparound). ‐ (B) FV‐0018 (Kerosene internal reflux). ‐ (B) FV‐0023 (LAGO Pumparound). ‐ (B) FV‐0024 (LAGO internal reflux). ‐ (B) FV‐0013 (HAGO Pumparound). ‐ (B) FV‐0022 (HAGO internal reflux). ‐ (B) FV‐0032 (G‐0014 minimum flow). (F) Close FV‐0019, FV‐0003, FV‐0018, FV‐0023, FV‐0024, FV‐0013, FV‐0022, and FV‐0032 bypass valves. (B) Verify control valves FV‐0015 A/B/C/D/E/F/G/H (Topped crude to F‐0001) are closed. (F) Close all utilities and flare connections in the section. (B) Open ZV‐0003 (MP emergency steam supply). (B/F) Ensure the entire atmospheric heater section, control valves inlet passes of F‐0001 to C‐ 0002, is open; including all the block valves, control valves and on‐off valves within the section. (F) Open all vents and drains included in the atmospheric heater section. Open C‐0002 top vent. (F) Steam out the entire section using MP steam for at least 12 hours. (F) Verify that oxygen content is less than 0.5% vol. (F) Limit drain valves to a 50%, once vapor starts coming out from all drain valves. (F) Limit vent valves to a 50%, once vapor starts coming out from all vent valves. (F) Leave C‐0002 top vent totally open.
STABLE STATE S2 Preflash section purged
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 15 of 39
LEVEL II STABLE STATE 2 SHEET STABLE STATE S2 Preflash section purged DESCRIPTION o Preflash section oxygen content is less than 0.5 %vol. o Steam is being continuously injected in the Preflash section and C‐0001 and C‐0002 top vent totally open. Shutoff of steam supply and pressurization with fuel gas is performed in step 700. UTILITIES o LP steam available. MATERIAL o Portable oxygen meters. SAFETY ◊ Extinguishers are in position and available. ◊ Steam hoses are available. ◊ Monitor hoses are available. ◊ Safety showers are available.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 16 of 39
LEVEL II ACTIONS 300
PURGING OF ATMOSPHERIC DISTILLATION SECTION
Note: Steps 310, 320, 330, 340, and 350 could be performed at the same time or independently. 310 PURGING OF OVERHEAD SECTION Note: The section comprises the following pieces of equipment: C‐0002, E‐0003 A/D (Shell Side), A‐ 0001 A/P, D‐0004, G‐0005 A/B, and inlet line to E‐0021. Note: Equipment suitable for steam out have not been designed for full vacuum conditions but for half vacuum. Attention shall be paid to that Administrative Controls which shall indicate that no steam out of an equipment can be done if the equipment is isolated; before starting the steam out of an equipment the vent (to atmosphere) shall be opened.
o o ◊
(F) Ensure that the overhead system is Isolated from other sections (Naphtha from C‐0002 overhead up to E‐0021). Check that the following items are closed and proceed to close if they are not in the right position: ‐ (B) ZV‐0122 and ZV‐0123 (Nitrogen injection line). ‐ (S/F) Block valves and blind on Corrosion inhibitor injection line, 1”‐INH‐011054002. ‐ (S/F) Block valves and blind on Neutralizing agent injection line, 1”‐CHP‐011054002. (B) Close control valves PV‐0033 A (Blanketing CDU reflux drum) and PV‐0033 B (Offgas CDU reflux drum). (F) Close PV‐0033 A and PV‐0033 B bypass valves. (F) Close all utilities and flare connections in the section. (F) Open block valves and blinds on CDU overhead line to E‐0003 A/B/C/D, 28”‐NPH‐ 011018001. (B/F) Ensure that the A‐0001 A/P motors are out service and they are is stop condition. (F) Open block valves and blind on Corrosion inhibitor injection line, 3”‐NPH‐011019008. (B) Open control valve FV‐0019 (CDU reflux). (F) Open FV‐0019 bypass valves. (F) Open block valve on Naphtha from G‐0005 to E‐0021 line, 6”‐NPH‐011019003. (F) Line‐up the pump G‐0005 through the individual suction/discharge valves. It will be purged with steam. (B/F) Ensure the entire overhead section, C‐0002 overhead up to E‐0021, is open; including all the block valves, control valves and on‐off valves within the section. (F) Open all vents and drains included in the overhead section. Open C‐0002 and D‐0004 top vents. (F) Open UC valves and steam out the entire section using LP steam for at least 12 hours. (F) Place a flexible LP steam hose connection to UC valve at C‐0002 bottom. (F) Verify that oxygen content is less than 0.5% vol. (F) Limit drain valves to a 50%, once vapor starts coming out from all drain valves. (F) Limit vent valves to a 50%, once vapor starts coming out from all vent valves. (F) Leave C‐0002 top vent totally open.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1 320 PURGING OF KEROSENE PUMPAROUND AND PRODUCT SECTION
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 17 of 39
Note: The section comprises the following pieces of equipment: ‐KERO PA involves C‐0002 draw‐off tray Nº 44, G‐0008 A/B and E‐0007 A‐B/D (Shell Side). ‐KERO product involves C‐0004, G‐0009 A/B, E‐0008, E‐0001, and E‐0023. Note: Equipment suitable for steam out have not been designed for full vacuum conditions but for half vacuum. Attention shall be paid to that Administrative Controls which shall indicate that no steam out of an equipment can be done if the equipment is isolated; before starting the steam out of an equipment the vent (to atmosphere) shall be opened.
o o ◊
(F) Ensure that the Kerosene PA and product section are isolated from other sections (Kerosene from C‐0002 tray Nº 44 up to battery limit). Check that the following items are closed and proceed to close if they are not in the right position: ‐ (S/F) Block valve and blind at battery limit on Kerosene product to LP HDS. ‐ (S/F) Block valve and blind at battery limit on Kerosene product to storage. (F) Close all utilities and flare connections in the section. (B) Open ZV‐0077 (Kerosene drawoff from tray Nº 44). (B) Open control valves FV‐0018 (Kerosene internal reflux) and FV‐0003 (Kerosene Pumparound). (F) Open FV‐0018 and FV‐0003 bypass valves. (B/F) Ensure the entire Kerosene PA and product section, C‐0002 tray Nº 44 to battery limit, is open; including all the block valves, control valves and on‐off valves within the section. (F) Line‐up the pumps G‐0008 A/B and G‐0009A/B through the individual suction/discharge valves. It will be purged with steam. (F) Open all vents and drains included in the kerosene PA and product section. Open C‐0002 and C‐0004 top vent. (F) Open UC valves and steam out the entire section using LP steam for at least 12 hours. (F) Verify that oxygen content is less than 0.5% vol. (F) Limit drain valves to a 50%, once vapor starts coming out from all drain valves. (F) Limit vent valves to a 50%, once vapor starts coming out from all vent valves. (F) Leave C‐0002 top vent totally open.
330 PURGING OF LIGHT ATMOSPHERIC GASOIL PUMPAROUND AND PRODUCT SECTION Note: The section comprises the following equipments: ‐LAGO PA involves C‐0002 draw‐off tray Nº 30, G‐0010 A/B, and E‐0013 (Shell Side). ‐LAGO product involves C‐0005, G‐0011 A/B, E‐0011 A/B (Shell Side), E‐0006 (Shell Side), E‐0024 (Shell Side), A‐0003 A/B and E‐0034. Note: Equipment suitable for steam out have not been designed for full vacuum conditions but for half vacuum. Attention shall be paid to that Administrative Controls which shall indicate that no steam out of an equipment can be done if the equipment is isolated; before starting the steam out of an equipment the vent (to atmosphere) shall be opened.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 18 of 39
o o ◊
(F) Ensure that the LAGO PA and product section is isolated from other sections (LAGO from C‐ 0002 tray Nº 30 up to battery limit). Check that the following items are closed and proceed to close if they are not in the right position: ‐ (S/F) Verify block valve and blind at battery limit on LAGO PA to Naphtha splitter reboiler in NDHT Unit 111. ‐ (S/F) Verify blind at battery limit associated to ZV‐0041 (LAGO PA from Naphtha splitter reboiler in NDHT Unit 111). ‐ (S/F) Verify blind at battery limit associated to ZV‐0045 (Wild Naphtha from HP HDS Unit 091). ‐ (B) ZV‐0092 (Stripping steam from F‐0001). ‐ (S/F) Verify block valve and blind at battery limit on LAGO product to LP HDS. ‐ (S/F) Verify block valve and blind at battery limit on LAGO product to storage. (F) Close all utilities and flare connections in the section. (B) Open ZV‐0078 (LAGO drawoff from tray Nº30). (B) Open ZV‐0041 (LAGO PA from Naphtha splitter reboiler in NDHT Unit 111). (B) Open ZV‐0045 (Wild Naphtha from HP HDS Unit 091). (B) Open the following control valves: ‐ (B) FV‐0024 (LAGO internal reflux). ‐ (B) PDV‐0385 (111‐E‐009 bypass). ‐ (B) FV‐0023 (LAGO Pumparound). (F) Open FV‐0024, PDV‐0385, and FV‐0023 bypass valves. (F) Open block valves and blinds located on Wild naphtha injection line to C‐0001 and C‐0002, 3”‐NPH‐011098002 and 3”‐NPH‐011098001 respectively. (B/F) Ensure the entire LAGO PA and product section, C‐0002 tray Nº 30 to battery limit, is open; including all the block valves, control valves and on‐off valves within the section. (F) Line‐up the pumps G‐0010 A/B and G‐0011 A/B through the individual suction/discharge valves. It will be purged with steam. (F) Open all vents and drains included in the LAGO PA and product section. Open C‐0002 and C‐ 0005 top vent. (F) Open UC valves and steam out the entire section using LP steam for at least 12 hours. (F) Verify that oxygen content is less than 0.5% vol. (F) Limit drain valves to a 50%, once vapor starts coming out from all drain valves. (F) Limit vent valves to a 50%, once vapor starts coming out from all vent valves. (F) Leave C‐0002 top vent totally open.
340 PURGING OF HEAVY ATMOSPHERIC GASOIL PUMPAROUND AND PRODUCT SECTION Note: The section comprises the following equipments: ‐HAGO PA involves C‐0002 draw‐off tray Nº 15, G‐0012 A/B, E‐0022(Tube Side), and E‐0017 A/B (Shell Side). ‐HAGO product involves C‐0006, G‐0013 A/B, E‐0012 A/B (Shell Side), E‐0009 A/B (Shell Side), E‐0002 (Tube Side), A‐0004 A/B and E‐0035. Note: Equipment suitable for steam out have not been designed for full vacuum conditions but for half vacuum. Attention shall be paid to that Administrative Controls which shall indicate that no steam out of an equipment can be done if the equipment is isolated; before starting the steam out of an equipment the vent (to atmosphere) shall be opened.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 19 of 39
o
o o ◊
(F) Ensure that the HAGO PA and product section is isolated from other sections (HAGO from C‐ 0002 tray Nº 15 up to battery limit). Check that the following items are closed and proceed to close if they are not in the right position: ‐ (S/F) Verify block valve and blind at battery limit on HAGO to Naphtha splitter reboiler in NDHT Unit 111. ‐ (S/F) Verify blind at battery limit associated to ZV‐0121 (HAGO PA from Naphtha splitter reboiler in NDHT Unit 111). ‐ (B) ZV‐0093 (Stripping steam from F‐0001). ‐ (S/F) Verify block valve and blind at battery limit on HAGO+LVGO product to HP HDS. ‐ (S/F) Verify block valve and blind at battery limit on HAGO+LVGO product to storage. ‐ (F) Block valve on LVGO injection line to HAGO line, 6”‐LGO‐011037007. (F) Close all utilities and flare connections in the section. (B) Open ZV‐0079 (HAGO drawoff from tray Nº15). (B) Open ZV‐0121 (HAGO PA from Naphtha splitter reboiler in NDHT Unit 111). Open the following control valves: ‐ (B) FV‐0022 (HAGO internal reflux) ‐ (B) PDV‐0384 (111‐E‐007 bypass) ‐ (B) FV‐0013 (HAGO Pumparound) (F) Open FV‐0022, PDV‐0384, and FV‐0013 bypass valves. (F) Open block valves located on LAGO injection line, 6”‐LGO‐011098002. (B/F) Ensure the entire HAGO PA and product section, C‐0002 tray Nº 15 to battery limit, is open; including all the block valves, control valves and on‐off valves within the section. (F) Line‐up the pumps G‐0012 A/B and G‐0013 A/B through the individual suction/discharge valves. It will be purged with steam. (F) Open all vents and drains included in the HAGO PA and product section. Open C‐0002 and C‐ 0006 top vent. (F) Open UC valves and steam out the entire section using LP steam for at least 12 hours. (F) Verify that oxygen content is less than 0.5% vol. (F) Limit drain valves to a 50%, once vapor starts coming out from all drain valves. (F) Limit vent valves to a 50%, once vapor starts coming out from all vent valves. (F) Leave C‐0002 top vent totally open.
350 PURGING OF ATMOSPHERIC RESIDUE SECTION Note: The atmospheric residue section comprises the following equipments: G‐0014 A/B, and the inlet lines of control flow valves to vacuum heater F‐0002. Note: Equipment suitable for steam out have not been designed for full vacuum conditions but for half vacuum. Attention shall be paid to that Administrative Controls which shall indicate that no steam out of an equipment can be done if the equipment is isolated; before starting the steam out of an equipment the vent (to atmosphere) shall be opened.
(B) Ensure that the Atmospheric residue section is isolated from other sections (Atmospheric residue from C‐0002 up to Vacuum heater F‐0002). Check that the control valves: HV‐0020 (Vacuum residue short recirculation), and FV‐0034 A/B/C/D/E/F/G/H (atmospheric residue to F‐ 0002) are closed and proceed to close if they are not in the right position: (F) Close HV‐0020 and FV‐0034 A/B/C/D/E/F/G/H bypass valves. (F) Close all utilities and flare connections in the section. (B) Open control valve FV‐0032 (G‐0014 minimum flow).
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 20 of 39
o o ◊
(F) Open FV‐0032 bypass valves. (B) Open ZV‐0006 (Atmospheric residue to G‐0014). (B/F) Ensure the entire atmospheric residue section, C‐0002 bottom line to vacuum heater F‐ 0002, is open; including all the block valves, control valves and on‐off valves within the section. (F) Line‐up the pumps G‐0014 A/B through the individual suction/discharge valves. It will be purged with steam. (F) Open all vents and drains included in the atmospheric residue section. (F) Open UC valves and steam out the entire section using LP steam for at least 12 hours. (F) Verify that oxygen content is less than 0.5% vol. (F) Limit drain valves to a 50%, once vapor starts coming out from all drain valves. (F) Limit vent valves to a 50%, once vapor starts coming out from all vent valves. (F) Leave C‐0002 top vent totally open.
STABLE STATE S3 Atmospheric Distillation section purged
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 21 of 39
LEVEL II STABLE STATE 3 SHEET STABLE STATE S3 Atmospheric Distillation section purged DESCRIPTION o Atmospheric distillation section oxygen content is less than 0.5 %vol. o Steam is being continuously injected in the atmospheric distillation section and C‐0002 top vent totally open. Shutoff of steam supply and pressurization with fuel gas is performed in step 700. UTILITIES o LP steam available. o MP steam available. MATERIAL o Portable oxygen meters. SAFETY ◊ Extinguishers are in position and available. ◊ Steam hoses are available. ◊ Monitor hoses are available. ◊ Safety showers are available.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 22 of 39
LEVEL II ACTIONS 400
PURGING OF VACUUM DISTILLATION SECTION
Note: Steps 410, 430, 440, 450 and 460 could be performed at the same time or independently. 410 PURGING OF VACUUM HEATER SECTION Note: The Vacuum Heater section comprises: Lines from control valves inlet passes to Vacuum heater F‐0002, Heater F‐0002 and the Vacuum Column C‐0003.
o ◊
(F) Ensure that the vacuum heater section is isolated from other sections (lines from control valves inlet passes to F‐0002 up to C‐0003). Check that the following items are closed and proceed to close if they are not in the right position: ‐ (S/F) Block valves and blinds on Neutralizing agent injection line, 1”‐CHP‐011054003. ‐ (B) ZV‐0083 (LVGO drawoff tray Nº10). ‐ (B) ZV‐0086 (MVGO drawoff tray Nº9). ‐ (B) ZV‐0081 (HVGO drawoff tray Nº 8). ‐ (S/F) Block valves downstream S‐0001 and bypass line on HVGO pumparound, 14”‐ HGO‐011013005 and 14”‐HGO‐011013004. ‐ (F) Block valves downstream S‐0002 and bypass line on Wash oil, 6”‐HGO‐011039018 and 6”‐HGO‐011039019. ‐ (B) ZV‐0021 (Stripping steam from F‐0002). ‐ (B) ZV‐0016 (Vacuum residue bottom outlet line). Close the following control valves: ‐ (B) FV‐0036 A/B/C/D/E/F/G/H (Dilution steam to F‐0002). ‐ (B) FV‐0038 (LVGO Pumparound return). ‐ (B) FV‐0046 (LVGO internal reflux). ‐ (B) FV‐0063 (Vacuum residue quench). (F) Close FV‐0036 A/B/C/D/E/F/G/H, FV‐0038, FV‐0046 and FV‐0063 bypass valves. (B) Verify control valves FV‐0034 A/B/C/D/E/F/G/H (atmospheric residue to F‐0002) are closed. (F) Close all utilities and flare connections in the section. (B/F) Ensure the entire vacuum heater section, control valves inlet passes of F‐0002 to C‐0003, is open; including all the block valves, control valves and on‐off valves within the section. (F) Open all vents and drains included in the vacuum heater section. Open C‐0003 top vent. (B) Open ZV‐0013 (MP emergency steam supply). (F) Steam out the entire section using MP steam for at least 12 hours. (F) Verify that oxygen content is less than 0.5% vol. (F) Limit drain valves to a 50%, once vapor starts coming out from all drain valves. (F) Limit vent valves to a 50%, once vapor starts coming out from all vent valves. (F) Leave C‐0003 top vent totally open.
420 PURGING OF VDU OFFGAS COMPRESSOR (F) Block in compressor K‐0001, VDU off gas compressor. Close valves listed below:
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 23 of 39
‐ K‐0001 suction line: block valves on line 6”‐VTG‐011034002. ‐ K‐0001 discharge line: block valves on line 4”‐VTG‐011035001. (F) Purge K‐0001 with nitrogen to remove oxygen.
Note: Please refer to the step 210 for the intermediate procedure 011‐IP‐0010 Compressor 011‐K‐ 0001 Shutdown/Degassing/ Gasssing /Start‐Up 430 PURGING OF OVERHEAD SECTION – VACUUM PACKAGE AND OFFGAS SYSTEM Note: The section comprises the following pieces of equipment: C‐0003 Overhead line, E‐0025 A/D (Shell Side), Vacuum Ejector Package, D‐0008, D‐0009, D‐0016, VDU off‐gas compressor is bypassed and inlet line to C‐0007 (ZV‐0027 closed) Note: Some equipment suitable for steam out have not been designed for full vacuum conditions but for half vacuum. Attention shall be paid to that Administrative Controls which shall indicate that no steam out of an equipment can be done if the equipment is isolated; before starting the steam out of an equipment the vent (to atmosphere) shall be opened.
o ◊
(F) Ensure that the vacuum package and offgas system is isolated from other sections (VDU overhead from C‐0003 up to Amine absorber C‐0007). Check that the following items are closed and proceed to close if they are not in the right position: ‐ (B) ZV‐0017 (MP steam supply to ejectors J‐0001 A/C, J‐0002 A/C, J‐0003 A/C ). ‐ (B) ZV‐0082 (Vent gas from D‐0009 to C‐0007 outlet). ‐ (B) ZV‐0027 (Vent gas to C‐0007 inlet). Close the following control valves: ‐ (B) PV‐0381 (Motive steam). ‐ (B) FV‐0152 (Recovered oil to slop header). ‐ (B) FV‐0153 (Recovered oil to HP HDS). (F) Close PV‐0381, FV‐0152 and FV‐0153 bypass valves. (F) Close all utilities and flare connections in the section. (F) Line‐up the pumps G‐0019 A/B and G‐0020 A/B through the individual suction/discharge valves. It will be purged with steam. (B/F) Ensure the entire overhead section, C‐0003 overhead to C‐0007, is open; including all the block valves, control valves and on‐off valves within the section. (F) Open all vents and drains included in the overhead section. Open C‐0003, D‐0009, D‐0016 and D‐0017 top vents. (F) Open UC valves and steam out the entire section (except compressor K‐0001) using LP steam for at least 12 hours. (F) Place a flexible LP steam hose connection to UC valve at C‐0003 bottom. (F) Verify that oxygen content is less than 0.5% vol. (F) Limit drain valves to a 50%, once vapor starts coming out from all drain valves. (F) Limit vent valves to a 50%, once vapor starts coming out from all vent valves. (F) Leave C‐0003 top vent totally open.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1 440 PURGING OF LIGHT VACUUM GASOIL PUMPAROUND AND PRODUCT SECTION
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 24 of 39
Note: The section comprises the following equipments: C‐0003 draw‐off tray Nº 10, G‐0015 A/B, E‐ 0005 (Shell Side), A‐0005 A/H, and E‐0029. Note: Equipment suitable for steam out have not been designed for full vacuum conditions but for half vacuum. Attention shall be paid to that Administrative Controls which shall indicate that no steam out of an equipment can be done if the equipment is isolated; before starting the steam out of an equipment the vent (to atmosphere) shall be opened.
o o ◊
(F) Ensure that the LVGO PA and product section is isolated from other sections (LVGO from C‐ 0003 tray Nº 10 up to battery limit). Check that the following items are closed and proceed to close if they are not in the right position: ‐ (S/F) Block valve and blind on HAGO+LVGO product to HP HDS. ‐ (S/F) Block valve and blind on HAGO+LVGO product to storage. (F) Close all utilities and flare connection in the section. (B) Open ZV‐0083 (HVGO drawoff tray Nº 10). (F) Open block valves and blind on LVGO injection line to HAGO line, 6”‐LGO‐011037007. (B) Open the following control valves: ‐ (B) FV‐0046 (LVGO internal reflux). ‐ (B) FV‐0038 (LVGO PA return). ‐ (B) FV‐0153(Recovered oil to LVGO injection line). (F) Open FV‐0046, FV‐0038 and FV‐0153 bypass valves. (B/F) Ensure the entire LVGO PA and product section, C‐0003 tray Nº 10 to battery limit, is open; including all the block valves, control valves and on‐off valves within the section. (F) Line‐up the pumps G‐0015 A/B through the individual suction/discharge valves. It will be purged with steam. (F) Open all vents and drains included in the LVGO PA and product section. Open C‐0003 top vent. (F) Open UC valves and steam out the entire section using LP steam for at least 12 hours. (F) Verify that oxygen content is less than 0.5% vol. (F) Limit drain valves to a 50%, once vapor starts coming out from all drain valves. (F) Limit vent valves to a 50%, once vapor starts coming out from all vent valves. (F) Leave C‐0003 top vent totally open.
450 PURGING OF MEDIUM AND HEAVY VACUUM GASOIL PUMPAROUND AND PRODUCT SECTION Note: The section comprises the following equipments: ‐C‐0003 draw‐off tray Nº 9, and G‐0016 A/B. ‐C‐0003 draw‐off tray Nº 8, G‐0017 A/B, E‐0019 A‐C/D‐F (Shell Side), E‐0016 A/B (Shell Side), E‐0015 A/B (Shell Side), E‐0010 A/B and E‐0030 A/B (Shell Side). Note: Equipment suitable for steam out have not been designed for full vacuum conditions but for half vacuum. Attention shall be paid to that Administrative Controls which shall indicate that no steam out of an equipment can be done if the equipment is isolated; before starting the steam out of an equipment the vent (to atmosphere) shall be opened.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 25 of 39
o o
(F) Ensure that the MVGO+HVGO PA and product section are isolated from other sections (MVGO+LVGO from C‐0003 tray Nº 9 and 8 respectively up to battery limit). Check that the following items are closed and proceed to close if they are not in the right position: ‐ (S/F) Block valve and blind on HVGO product to DHC/MHC. ‐ (S/F) Block valve and blind on HVGO product to storage. (F) Close all utilities and flare connections in the section. (B) Open ZV‐0086 (MVGO drawoff tray Nº9). (B) Open ZV‐0081 (HVGO drawoff tray Nº8). (F) Open block valves downstream S‐0001 and bypass line on HVGO PA, 14”‐HGO‐011013005, 14”‐HGO‐011013003 and 14”‐HGO‐011013004. (F) Open block valves downstream S‐0002 and bypass line on Wash oil, 6”‐HGO‐011039018, 6”‐ HGO‐011039013 and 6”‐HGO‐011039019. (F) Open block valves on HAGO from E‐0035 injection point to HVGO line, 6”‐HGO‐011098005. (B/F) Ensure the entire MVGO+HVGO PA and product section, C‐0003 tray Nº 9 and 8 to battery limit, is open; including all the block valves, control valves and on‐off valves within the section. (F) Line‐up the pumps G‐0016 A/B and G‐0017 A7B through the individual suction/discharge valves. It will be purged with steam. (F) Open all vents and drains included in the MVGO+HVGO PA and product section. Open C‐ 0003 top vent. (F) Open UC valves and steam out the entire section using LP steam for at least 12 hours. (F) Verify that oxygen content is less than 0.5% vol. (F) Limit drain valves to a 50%, once vapor starts coming out from all drain valves. (F) Limit vent valves to a 50%, once vapor starts coming out from all vent valves. (F) Leave C‐0003 top vent totally open.
◊ Note: Refer to intermediate procedure 011‐IP‐0023 and 011‐IP‐0024 for filters S‐0001 and S‐0002 gassing procedure. 460 PURGING OF VACUUM RESIDUE SECTION
Note: The Vacuum residue section comprises the following equipments: G‐0018 A/B, E‐0020 A‐B/C‐D (Shell Side), E‐0018 A‐B/C‐D (Shell Side), E‐0014 A‐C/D‐F (Shell Side), E‐0031 A‐B (Shell Side).
Note: Equipment suitable for steam out have not been designed for full vacuum conditions but for half vacuum. Attention shall be paid to that Administrative Controls which shall indicate that no steam out of an equipment can be done if the equipment is isolated; before starting the steam out of an equipment the vent (to atmosphere) shall be opened.
(F) Ensure that the vacuum residue section is isolated from other sections (Vacuum residue from C‐0003 up to battery limit). Check that the following items are closed and proceed to close if they are not in the right position: ‐ (S/F) Block valve and blind on Vacuum residue to Coker unit. ‐ (S/F) Block valve and blind on Vacuum residue to storage. (F) Close all utilities and flare connections in the section. (B) Open ZV‐0016 (Vacuum residue to G‐0018 A/B). (B/F) Open the appropriate valves on the start‐up lines or intermittent use lines: ‐ (F) VDU bypass line from G‐0014: Block valves on line 12”‐RES‐011027005.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 26 of 39
o o ◊
‐ (F) Short recirculation line from G‐0018 A/B: Block valves on line 10”‐RES‐011039004. ‐ (B) HV‐0020 (Vacuum residue short recirculation). (B) Open control valves FV‐0063 (Vacuum residue quench). (F) Open FV‐0063 bypass valve. (B) (F) Ensure the entire vacuum residue section, C‐0003 bottom to battery limit, is open; including all the block valves, control valves and on‐off valves within the section. (F) Line‐up the pumps G‐0018A/B through the individual suction/discharge valves. It will be purged with steam. (F) Open all vents and drains included in the LVGO PA and product section. Open C‐0003 top vent. (F) Open UC valves and steam out the entire section using LP steam for at least 12 hours. (F) Verify that oxygen content is less than 0.5% vol. (F) Limit drain valves to a 50%, once vapor starts coming out from all drain valves. (F) Limit vent valves to a 50%, once vapor starts coming out from all vent valves. (F) Leave C‐0003 top vent totally open.
STABLE STATE S4 Vacuum Distillation section purged
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 27 of 39
LEVEL II STABLE STATE 4 SHEET STABLE STATE S4 Vacuum Distillation section purged DESCRIPTION o Vacuum distillation section oxygen content is less than 0.5 %vol. o Steam is being continuously injected in the vacuum distillation section and C‐0003 top vent totally open. Shutoff of steam supply and pressurization with fuel gas is performed in step 700. UTILITIES o Nitrogen available. MATERIAL o Portable oxygen meters. SAFETY ◊ Extinguishers are in position and available. ◊ Steam hoses are available. ◊ Monitor hoses are available. ◊ Safety showers are available. ◊ Personal warning system are provide (like hydrogen sulphide detectors)
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 28 of 39
LEVEL II ACTIONS 500
PURGING OF AMINE SECTION
o
(F) Ensure that the amine section is isolated from other sections (Lean amine from battery limit and offgas line from D‐0017 up to Rich amine battery limit). Check that the following items are closed and proceed to close if they are not in the right position: ‐ (B) Verify ZV‐0027 (Vent gas to C‐0007 inlet). ‐ (F) Verify block valve and blind at battery limit on Lean amine from amine regeneration Unit 203. ‐ (B) ZV‐0029 (Offgas to flare). ‐ (B) Verify ZV‐0082 (Vent gas from D‐0009 to C‐0007 outlet) ‐ (F) Manual cock valves on offgas burners inlets to F‐0002 cell 1 and cell 2. ‐ (F) Verify block valve and blind at battery limit on Rich amine to amine regeneration unit 203. (F) Close all utilities and flare connections in the section. (B/F) Ensure the entire Amine section, Lean amine from battery limit and offgas line from D‐ 0017 to Rich amine battery limit, is open; including all the block valves, control valves and on‐ off valves within the section. (F) Increase gradually the nitrogen flow to the system by flexible hose to the utility connection through line 2”‐AMN‐011036023 and increase the pressure in C‐0007. (B/F) Monitoring pressure system in PT‐0113 (column C‐0007 overhead).
Note: It could also be used others connections within the Amine system to pressurize it with nitrogen.
(F) Pressurize the system up to 1.0 barg. Note: Among others pressure indicators around the system, the pressure could be checked on PI‐0116 on C‐0007 overhead. Note: Care must be taken as the design pressure of this section is lower than nitrogen supply normal pressure. Hence, a continuous follow‐up of the system pressure shall be done, controlling the N2 entrance to the system through the manual valve available in the N2 injection line
(F) Vent directly to atmosphere through column top vent, and line vents. Vents should be opened and a good plume of gas established.
Note: With nitrogen purging to the atmosphere extreme care should be taken to protect operator/ contractor personal
(F) Drain any condensate as rapidly as it forms through drains on equipment and low points in the lines. (F) Pressure up to 1 barg and de‐pressure several times until the oxygen content is lower than 0.5% vol. Usually three cycles are required to reach the desired value. (F) Close all drains when no liquid comes out of the drains.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 29 of 39
(F) Close vents and stop the nitrogen supply when the system has been thoroughly purged. (F) Fill the system with nitrogen to maintain a slight positive pressure, 0.3 barg. Note: Under no circumstances should nitrogen/air mixture be vented into the flare system as it could lead to explosive atmospheres within the flare system. Note: Inerting with Nitrogen may also be performed from compressor K‐0001 up to column C‐0007. If this alternative is chosen, control valves PV‐0308 and LV‐0070 should be closed and ZV‐0027 opened. Refer to step 300 for the intermediate procedure 011‐IP‐0011 Amine Section.
STABLE STATE S5 Amine section purged
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 30 of 39
LEVEL II STABLE STATE 5 SHEET STABLE STATE S5 Amine section purged DESCRIPTION o Amine section oxygen content is less than 0.5 %vol. o Positive nitrogen pressure (0.3 barg) is maintained in Amine section. UTILITIES o LP steam available. MATERIAL o Portable oxygen meters. SAFETY ◊ Extinguishers are in position and available. ◊ Steam hoses are available. ◊ Monitor hoses are available. ◊ Safety showers are available.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 31 of 39
LEVEL II ACTIONS 600
PURGING OF SLOP COOLING SYSTEM
Note: The Slop Cooling system consists by the exchanger E‐0037 A‐B/C‐D (Shell Side), to Slop & CDU/VDU long recirculation BL. Note: Equipment suitable for steam out has not been designed for full vacuum conditions but for half vacuum. Attention shall be paid to that Administrative Controls which shall indicate that no steam out of an equipment can be done if the equipment is isolated; before starting the steam out of an equipment the vent (to atmosphere) shall be opened.
◊
(F) Ensure that slop cooling section is isolated. Check that the following items are closed and proceed to close if they are not in the right position: ‐ (F) Block valve and blind at battery limit on Slop long recirculation Unit 661. ‐ (F) Block valve and blind at battery limit on Slop to Unit 681. (F) Close all utilities and flare connections in the section. (F) Open block valves located on off‐spec product lines to E‐0037 (Naphtha from header, HAGO from E‐0035, LAGO from E‐0034, Kerosene from E‐0023, and LVGO from E‐0029). (B) Open control valve FV‐0152. (F) Open FV‐0152 bypass valve. (F) Open all vents and drains included in the slop cooling system. (F) Open UC valves and steam out the entire section using LP steam for at least 12 hours. (F) Verify that oxygen content is less than 0.5% vol. (F) Limit drain valves to a 50%, once vapor starts coming out from all drain valves. (F) Limit vent valves to a 50%, once vapor starts coming out from all vent valves.
STABLE STATE S6 Slop cooling system purged
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 32 of 39
LEVEL II STABLE STATE 6 SHEET STABLE STATE S6 Slop cooling system purged DESCRIPTION o Slop cooling system oxygen content is less than 0.5 % vol. o CDU/VDU unit oxygen content is less than 0.5 % vol. o Steam is being continuously injected in the CDU/VDU unit and C‐0001, C‐0002 and C‐0003 top vents are totally open. Shutoff of steam supply and pressurization with fuel gas is performed in step 700. Note: Previous to introducing fuel gas to the unit for pressurizing, the tightness test and Vacuum Test of the VDU column shall be done. These activities shall be covered by a dedicated procedure developed by Operation Group. o
o
TIGHTNESS TEST OF THE VACUUM SYSTEM could be done after steps 400 and 500 have been completed. This can be done by pressurizing the Vacuum tower, Vacuum Ejector Package and Vacuum Heater with Nitrogen and observing the flange connections to determine possible leakage. The leak test is satisfactory when the maximum drop pressure is lower than 0.05 barg/hour over a period of 4 consecutive hours. VACUUM TEST could be done following the steam tightness test; a vacuum test is made on the vacuum tower system to check for any possible leaks that were not disclosed by the tightness test. ‐ Evacuation test, when required, are used to determine “commercially tight system”. System should be evacuated to 130 mm Hg. abs and leakage checked using the heat exchanger Institute’s “Standard for Steam Jet Ejectors”. ‐ The cooling water system should be put into operation with water flowing through of precondensers E‐0025 A‐D, first stage condenser E‐0026, second stage condenser, E‐0027 and third stage condenser E‐0028. Before starting steam to the vacuum jets, all low point drains in the tower system (including strippers) should be opened to drain all water from system. Start steam to the vacuum jets. ‐ Normally only two sets of three jets are used, however for that vacuum test pull out all of the system, use all three sets. Allow all jets to operate for about one‐half hour with all drains open, pulling air in from the atmosphere, this will help to dry the systems so that equilibrium at full vacuum may be reached faster. ‐ To star the vacuum jets, open all vapour discharged valves, then start steam to jets, J‐0001 A/B/C, J‐0002 A/B/C and J‐0003 A/B/C. Start with 3rd and 2nd stage in that order. ‐ When condensate level appears in the vacuum condensate accumulator, LT‐0058, start‐up pumps G‐0019 A/B. ‐ When the vacuum system pressure is less than 78 mm Hg abs shut off the steam to J‐ 0001 A/B/C, J‐0002 A/B/C and EJ‐0003 A/B/C, in that order.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 33 of 39
‐
Pressure readings from PT‐0067, PI‐0075&0494&0495, PI‐0104, PI‐0105, PI‐0077, PI‐ 0078, PT‐0083, and PT‐0308 should be logged every 15 minutes and if the pressure increase is less than 15 mm Hg or 0.02 bar per hour, this would indicated excessive air leakage into the system and checked for leaks must be made and all leaks repaired before oil is admitted to the unit. After a satisfactory vacuum test has been obtained, the unit is ready for the oil charge. The vacuum ejectors are then restarted.
UTILITIES Note: Once the unit has been completely purged (oxygen content less than 0.5 % volume), proceed to start‐up the Fuel Gas and Pilot Gas system as per 011‐IP‐0015‐1 (Section 400) and 011‐IP‐0015‐2 (Section 400) respectively. Once the Fuel gas system has been started‐up, proceed with the Flare start‐up as per 011‐IP‐0016, section 400. Once the Flare system has been started‐up, align the Closed Drain vent to the Flare as per 011‐IP‐ 0017, section 200. o
Fuel gas ready to use (For step 700).
SAFETY ◊ Extinguishers are in position and available. ◊ Steam hoses are available. ◊ Monitor hoses are available. ◊ Safety showers are available.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 34 of 39
LEVEL II ACTIONS 700
PRESSURE UNIT USING FUEL GAS
710 PRESSURE THE FEED AND PREFLASH SECTION o After oxygen content is less than 0.5% vol: o (F) Verify that block valves and blinds located on D‐0001 and D‐0002 bypass lines 16”‐CRD‐ 011006001 and 16”‐CRD‐011007006 are open. (B) Open control valves FV‐0015 A/B/C/D/E/F/G/H (Topped crude to F‐0001). (F) Open FV‐0015 A/B/C/D/E/F/G/H bypass valves. (F) Close all vents and drains. (F) Stop LP steam and MP steam supply. (B) Open control valve PV‐0038 A (D‐0005 Blanketing). (F) Open PV‐0038 A bypass valve. (F) Pressure with Fuel gas, immediately after steam has been shut off, up to 0.3 barg through line 3”‐FUG‐011021301 located on D‐0005 overhead. Observing the system pressure through PT‐0038. Note: Pressuring with Fuel gas immediately prevents any possibility of a vacuum occurring as the steam condenses. As fuel gas is admitted, the system will cool down and condensate can be drained off. 720 PRESSURE THE ATMOSPHERIC DISTILLATION SECTION o After oxygen content is less than 0.5% vol: (B) Open control valves: FV‐0034 A/B/C/D/E/F/G/H (Atmospheric residue to F‐0002). (F) Open FV‐0034 A/B/C/D/E/F/G/H bypass valves. (F) Close all vents and drains. (F) Stop LP steam supply. (B) Open control valve PV‐0033 A (D‐0004 Blanketing). (F) Open PV‐0033 A bypass valve. (F) Pressure with Fuel gas, immediately after steam has been shut off, up to 0.3 barg through line 3”‐FUG‐011019301 located on D‐0004 overhead. Note: Pressuring with Fuel gas immediately prevents any possibility of a vacuum occurring as the steam condenses. As fuel gas is admitted, the system will cool down and condensate can be drained off. 730 PRESSURE THE VACUUM DISTILLATION SECTION o After oxygen content is less than 0.5% vol: (F) Close all vents and drains. (F) Stop LP steam and MP steam supply. (F) Pressure with Fuel gas, immediately after steam has been shut off, up to 0.3 barg through line 2”‐FUG‐011034301 located upstream D‐0016.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 35 of 39
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1 Note: Pressuring with Fuel gas immediately prevents any possibility of a vacuum occurring as the steam condenses. As fuel gas is admitted, the system will cool down and condensate can be drained off.
STATE FINAL
CDU/VDU Unit purged and pressurized
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 36 of 39
LEVEL II FINAL STATE SHEET FINAL STATE CDU/VDU Unit Ready for start‐up DESCRIPTION o Unit oxygen content is less than 0.5 vol%. o Positive pressure is maintained in the entire Unit: ‐ Fuel gas pressure (0.3 barg): feed, preflash atmospheric heater, atmospheric distillation, vacuum heater, vacuum distillation, and slop cooling sections. ‐ Nitrogen pressure (0.3 barg): desalting water, desalter, offgas compressor, amine sections. o Desalting water section is isolated. Following items are in close position: ‐ Block valve and blind at battery limit on Non phenolic stripped water from Unit 213. ‐ Block valve and blind at battery limit on Phenolic stripped water from Unit 211. ‐ Block valves on desalting water injection lines, 4”‐PRW‐01142005 and 6”‐PRW‐ 011042006. ‐ FV‐0059 A (BFW supply) and PV‐0311 B (D‐0007 vent to flare). o Desalter section is isolated. Following items are in close position: ‐ ZV‐0087 and ZV‐0088 (Desalter D‐0001 and D‐0002 inlets). ‐ Block valves on outlet line of desalter D‐0001, 18”‐CRD‐011006002. ‐ Block valves on outlet line of desalter D‐0002, 18”‐CRD‐011007002. ‐ Block valves on Desalting water injection line 6”‐BRN‐011007002. ‐ Block valve and blind at battery Brine to WWT Unit 651. o VDU Offgas compressor is isolated. Following items are in close position: ‐ K‐0001 suction line: block valves on line 6”‐VTG‐011034002. ‐ K‐0001 discharge line: block valves on line 4”‐VTG‐011035001. o Amine section is isolated. Following items are in close position: ‐ ZV‐0027 (Vent gas to C‐0007 inlet). ‐ ZV‐0029 (Offgas to flare). ‐ ZV‐0082 (Vent gas from D‐0009 to C‐0007 outlet) ‐ Manual cock valves on offgas burners inlets to F‐0002 cell 1 and cell 2. ‐ Block valve and blind at battery limit on Lean amine from amine regeneration unit. ‐ Block valve and blind at battery limit on Rich amine to amine regeneration unit 203.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 37 of 39
o
Feed, preflash atmospheric heater, atmospheric distillation, vacuum heater, and vacuum distillation section are aligned and isolated by the following items at battery limit: ‐ Block valves and blinds on Crude feed. ‐ Block valves and blinds on Slop feed from storage. ‐ Blind on Wild Naphtha from HP HDS Unit 091. ‐ Block valve and blind on Naphtha product to NHDT Unit 111. ‐ Block valve and blind on Kerosene product to LP HDS. ‐ Block valve and blind on Kerosene product to storage. ‐ Block valve and blind on LAGO PA to Naphtha splitter reboiler in NDHT Unit 111. ‐ Blind on LAGO PA from Naphtha splitter reboiler in NDHT Unit 111. ‐ Block valve and blind on LAGO product to LP HDS. ‐ Block valve and blind on LAGO product to storage. ‐ Block valve and blind on HAGO to Naphtha splitter reboiler in NDHT Unit 111. ‐ Blind on HAGO PA from Naphtha splitter reboiler in NDHT Unit 111. ‐ Block valve and blind on HAGO+LVGO product to HP HDS. ‐ Block valve and blind on HAGO+LVGO product to storage. ‐ Block valve and blind on HVGO product to DHC/MHC. ‐ Block valve and blind on HVGO product to storage. ‐ Block valve and blind on Vacuum residue to Cocker unit. ‐ Block valve and blind on Vacuum residue to storage.
o
Pumps G‐0005 and G‐0020 are isolated through the individual suction/discharge valves.
o
Chemical injections points, Demulsifier, Corrosion and Neutralising, block valves and blinds are in closed position.
o
Vent and drains valves are in close position.
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 38 of 39
LEVEL IV Abbreviation CDU: Crude Distillation Unit VDU: Vacuum Distillation Unit LP: Low Pressure MP: Medium Pressure HP: High Pressure BFW: Boiler Feed water WWT: Waste Water Treatment NHDT: Naphtha Hydrotreater HDS: Hydrodesulphurisation DHC: Distillate Hydrocracker MHC: Mild Hydrocracker LAGO: Light Atmospheric Gasoil HAGO: Heavy Atmospheric Gasoil LVGO: Light Vacuum Gasoil MVGO: Medium Vacuum Gasoil HVGO: Heavy Vacuum Gasoil PA: Pumparound BL: Battery Limit UC: Utility connection
INTERMEDIATE PROCEDURE FOR
CDU/VDU PREPARATION FOR START UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
BLIND LIST
Procedure No. 011‐IP‐0001 Date: 21‐OCT‐2011 Rev. : 01 Pag. : 39 of 39
CDU/VDU UNIT (UNIT 011) BLIND LIST
CDU/VDU UNIT (UNIT 011) BLIND LIST
Line number
P&ID
Service
Line number
P&ID
Service
1"-CRD-011018004-101CL4P-P 8"-VTG-011034002-101CH4S-S 3/4"-HGO-011024008-103CL2P-P 2"-HGO-011024008-103CL2P-P 2"-NPH-011021015-103CH2S-N 3/4"-NPH-011021015-103CH2S-N 2"-NPH-011021016-103CH2S-N 3/4"-NPH-011021016-103CH2S-N 3/4"-KER-011022018-103CS1P-P 2"-KER-011022018-103CS1P-P 2"-KER-011022019-103CS1P-P 3/4"-KER-011022019-103CS1P-P 2"-NPH-011019025-101CH2S-P 3/4"-SRW-011019004-101CH2S-N 2"-NPH-011021011-103CH2S-N 2"-KER-011022010-101CS1P-P 2"-SLP-011001001-103CS1P-N 2"-NPH-011012007-101CH2S-P 3/4"-NPH-011012008-101CH2S-P 2"-NPH-011012008-101CH2S-P 3/4"-NPH-011012009-101CH2S-P 2"-NPH-011012009-101CH2S-P 3/4"-NPH-011003006-101CH2S-P 3/4"-NPH-011003005-101CH2S-P 3/4"-HGO-011024009-103CL2P-P 2"-HGO-011024009-103CL2P-P 3"-SRW-011031001-101CH4S-N 2"-SRW-011036001-101CH2S-N 4"-VTG-011033001-101CH4S-N 10"-VTG-011033002-101CH4S-N 3"-SRW-011031004-101CH4S-N 4"-LPS-011022301-101CS1P-H 4"-LPS-011022301-101CS1P-H 3/4"-KER-011022011-103CS1P-P 3"-KER-011022011-103CS1P-P 3/4"-KER-011022011-103CS1P-P 2"-CRD-011005013-106CS1P-P 2"-KER-011005002-103CS1P-P 2"-NPH-011020005-101CH2S-P 2"-HGO-011005009-103CL2P-P 2"-CRD-011005015-106CS1P-P 2"-CRD-011005014-106CS1P-P 2"-HGO-011099003-103CS1P-P 2"-RES-011099003-103CS1P-P 2"-RES-011015010-103CL4P-P 2"-RES-011010005-103CL2P-S 18"-KER-011026004-101CS1P-H 18"-KER-011026003-101CS1P-H 16"-LGO-011026003-103CS2P-H 20"-LGO-011026001-103CS2P-H 16"-LGO-011026005-103CS2P-H 20"-LGO-011026002-103CS2P-H 2"-HGO-011022003-103CL2P-P 16"-KER-011026001-101CS1P-H 16"-KER-011026005-101CS1P-H 28"-NPH-011018001-101CH2S-P 4"-HGO-011022004-103CL2P-P 8"-HGO-011038002-103CL2P-S 2"-HGO-011038014-103CL2P-S 2"-CRD-011014003-106CS2P-P
DS011-TRJR-480044 DS011-TRJR-480091 DS011-TRJR-480057 DS011-TRJR-480057 DS011-TRJR-480051 DS011-TRJR-480051 DS011-TRJR-480051 DS011-TRJR-480051 DS011-TRJR-480053 DS011-TRJR-480053 DS011-TRJR-480053 DS011-TRJR-480053 DS011-TRJR-480046 DS011-TRJR-480046 DS011-TRJR-480051 DS011-TRJR-480052 DS011-TRJR-480001 DS011-TRJR-480022 DS011-TRJR-480022 DS011-TRJR-480022 DS011-TRJR-480022 DS011-TRJR-480022 DS011-TRJR-480005 DS011-TRJR-480005 DS011-TRJR-480057 DS011-TRJR-480057 DS011-TRJR-480086 DS011-TRJR-480086 DS011-TRJR-480086 DS011-TRJR-480086 DS011-TRJR-480086 DS011-TRJR-480052 DS011-TRJR-480052 DS011-TRJR-480052 DS011-TRJR-480052 DS011-TRJR-480052 DS011-TRJR-480009 DS011-TRJR-480009 DS011-TRJR-480048 DS011-TRJR-480010 DS011-TRJR-480010 DS011-TRJR-480010 DS011-TRJR-480138 DS011-TRJR-480138 DS011-TRJR-480029 DS011-TRJR-480019 DS011-TRJR-480063 DS011-TRJR-480063 DS011-TRJR-480064 DS011-TRJR-480064 DS011-TRJR-480064 DS011-TRJR-480064 DS011-TRJR-480052 DS011-TRJR-480063 DS011-TRJR-480063 DS011-TRJR-480004 DS011-TRJR-480052 DS011-TRJR-480099 DS011-TRJR-480099 DS011-TRJR-480027
CRUDE SOUR OFF GAS HAGO HAGO NAPHTHA NAPHTHA NAPHTHA NAPHTHA KERO KERO KERO KERO NAPHTHA SOUR WATER NAPHTHA KERO SLOP OIL NAPHTHA NAPHTHA NAPHTHA NAPHTHA NAPHTHA WET NAPHTHA WET NAPHTHA HAGO HAGO SOUR WATER SOUR WATER SOUR OFF GAS SOUR OFF GAS SOUR WATER LP STEAM LP STEAM KERO KERO KERO FRESH CRUDE KERO NAPHTHA HAGO FRESH CRUDE FRESH CRUDE HEAVY GAS OIL RESIDUE VACUUM RESIDUE VACUUM RESIDUE KERO KERO LAGO LAGO LAGO LAGO HAGO KERO KERO HEAVY NAPHTHA HAGO MVGO MVGO CRUDE
8"-HGO-011038001-103CL2P-S 24"-NPH-011002001-101CH2S-P 12"-CRD-011001007-106CS1P-H 2"-KER-011022012-101CS1P-P 2"-HGO-011022005-103CL2P-P 12"-CRD-011002002-106CS1P-H 2"-CRD-011002003-106CS1P-P 2"-NPH-011002002-101CH2S-P 28"-NPH-011018001-101CH2S-P 2"-NPH-011020003-101CH2S-P 2"-NPH-011020003-101CH2S-P 2"-KER-011026006-101CS1P-P 3/4"-KER-011026006-101CS1P-P 2"-KER-011026007-101CS1P-P 3/4"-KER-011026007-101CS1P-P 2"-LGO-011026006-103CS2P-P 3/4"-LGO-011026006-103CS2P-P 2"-LGO-011026007-103CS2P-P 3/4"-LGO-011026007-103CS2P-P 2"-OIL-011033006-103CH2S-N 2"-KER-011025008-103CS1P-N 2"-LGO-011200002-103CS1P-N 2"-KER-011025003-103CS1P-P 2"-HGO-011200003-103CS1P-N 2"-SRW-011200004-106CH2S-N 3/4"-HGO-011038012-103CL2P-S 2"-PRW-011043008-101CS2P-P 2"-PRW-011043017-101CS2P-P 1"-RES-011030003-101CL4P-S 2"-KER-011025007-103CS1P-N 2"-LGO-011010003-103CS2P-P 2"-HGO-011015006-103CL2P-S 2"-BDH-011200002-101CS1P-N 1-1/2"-DWA-011054301-101SR0P-N 2"-CRD-011015012-106CL2P-P 12"-NPH-011012003-101CH2S-P 2"-HGO-011025012-103CS1P-P 2"-SLP-011098016-103CS1P-P 2"-SLP-011098017-103CS1P-P 1-1/2"-HGO-011025012-103CS1P-P 2"-NPH-011200005-103CH2S-N 12"-CRD-011001007-106CS1P-H 12"-CRD-011002002-106CS1P-H 24"-NPH-011002001-101CH2S-P 2"-CRD-011002004-106CS1P-P 2"-NPH-011002003-101CH2S-P 2"-CRD-011002005-106CS1P-N 2"-LGO-011025010-103CS1P-N 2"-LGO-011025005-103CS1P-N 2"-LGO-011025011-103CS1P-N 3/4"-NPH-011019009-101CH2S-P 2"-NPH-011019009-101CH2S-P 2"-RES-011030008-101CM2P-S 3/4"-LGO-011037011-103CS1P-P 2"-LGO-011037011-103CS1P-P 2"-BRN-011200003-103CS4P-N 2"-CRD-011003009-106CS1P-P 3/4"-SRW-011019004-101CH2S-P 4"-SRW-011019004-101CH2S-P 3/4"-SRW-011019004-101CH2S-N
DS011-TRJR-480099 DS011-TRJR-480004 DS011-TRJR-480004 DS011-TRJR-480052 DS011-TRJR-480052 DS011-TRJR-480004 DS011-TRJR-480004 DS011-TRJR-480004 DS011-TRJR-480004 DS011-TRJR-480048 DS011-TRJR-480048 DS011-TRJR-480063 DS011-TRJR-480063 DS011-TRJR-480063 DS011-TRJR-480063 DS011-TRJR-480064 DS011-TRJR-480064 DS011-TRJR-480064 DS011-TRJR-480064 DS011-TRJR-480087 DS011-TRJR-480058 DS011-TRJR-480274 DS011-TRJR-480058 DS011-TRJR-480274 DS011-TRJR-480274 DS011-TRJR-480099 DS011-TRJR-480112 DS011-TRJR-480112 DS011-TRJR-480081 DS011-TRJR-480058 DS011-TRJR-480018 DS011-TRJR-480028 DS011-TRJR-480274 DS011-TRJR-480128 DS011-TRJR-480028 DS011-TRJR-480023 DS011-TRJR-480061 DS011-TRJR-480136 DS011-TRJR-480136 DS011-TRJR-480061 DS011-TRJR-480274 DS011-TRJR-480004 DS011-TRJR-480004 DS011-TRJR-480004 DS011-TRJR-480004 DS011-TRJR-480004 DS011-TRJR-480004 DS011-TRJR-480060 DS011-TRJR-480060 DS011-TRJR-480060 DS011-TRJR-480045 DS011-TRJR-480045 DS011-TRJR-480081 DS011-TRJR-480096 DS011-TRJR-480096 DS011-TRJR-480274 DS011-TRJR-480006 DS011-TRJR-480046 DS011-TRJR-480046 DS011-TRJR-480046
MVGO HEAVY NAPHTHA FRESH CRUDE KERO HAGO FRESH CRUDE FRESH CRUDE HEAVY NAPHTHA HEAVY NAPHTHA NAPHTHA NAPHTHA KERO KERO KERO KERO LAGO LAGO LAGO LAGO RECOVERED LVGO KERO LAGO KERO HAGO SOUR WATER MVGO WATER WATER VACUUM RESIDUE KERO LAGO HVGO WATER DEMINERALIZED WATER TOPPED CRUDE NAPHTHA HAGO SLOP OIL SLOP OIL HAGO TOTAL NAPHTHA FRESH CRUDE FRESH CRUDE HEAVY NAPHTHA FRESH CRUDE HEAVY NAPHTHA FRESH CRUDE LAGO LAGO LAGO NAPHTHA HEAVY NAPHTHA ATM. RESIDUE LVGO LVGO BRINE FRESH CRUDE SOUR WATER SOUR WATER SOUR WATER
CDU/VDU UNIT (UNIT 011) BLIND LIST
CDU/VDU UNIT (UNIT 011) BLIND LIST
Line number
P&ID
Service
Line number
P&ID
Service
2"-HGO-011025006-103CS1P-N 2"-HGO-011025005-103CS1P-N 2"-CRD-011016003-106CL2P-P 8"-NPH-011021002-103CH2S-N 4"-LPS-011041004-101CS1P-P 2"-LPS-011041007-101CS1P-P 1"-VTG-011230301-101CS1P-N 3/4"-LGO-011030006-101CS1P-P 2"-CLD-011006307-103CH2S-P 1"-LPN-011230301-101CS1P-N 1"-INA-011230301-301CG2P-N 1-1/2"-AWR-011230301-101CS1P-N 1-1/2"-AWS-011230301-101CS1P-N 3/4"-NPH-011021005-101CH2S-N 2"-KER-011200001-103CS1P-N 2"-CRD-011010007-103CS1P-P 2"-CRD-011010005-101CH2S-P 6"-FLO-011077301-101CS1P-N 1"-CHP-011053001-103SC1P-N 6"-HGO-011005005-103CL2P-H 12"-CRD-011005001-106CS1P-H 10"-PRW-011043002-101CS1P-N 2"-OIL-011033008-103CH2S-N 2"-OSW-011035301-101CS1P-N 4"-VTG-011035001-101CH4S-P 4"-AWS-011035301-101CS1P-N 4"-AWR-011035301-101CS1P-N 32"-VAC-011032001-101CH4S-P 2"-RES-011028001-103CL4P-S 2"-RES-011028002-103CL4P-S 3/4"-PRW-011043002-101CS1P-N 3/4"-PRW-011043002-101CS1P-N 2"-AMD-011200002-103CH2S-N 2"-CRD-011016006-106CL2P-P 2"-CRD-011016007-106CL2P-P 2"-CRD-011016008-106CL2P-P 2"-CRD-011016009-106CL2P-P 2"-RES-011040018-103CS1P-P 2"-RES-011040019-103CS1P-P 4"-LPS-011041003-101CS1P-P 2"-CRD-011016004-106CL2P-P 2"-CRD-011016005-106CL2P-P 2"-CRD-011009002-103CS1P-P 2"-HGO-011013003-103CL2P-P 2"-CRD-011009003-103CS1P-P 2"-HGO-011009003-103CL2P-P 3/4"-LGO-011037023-103CS1P-N 2"-LGO-011037023-103CS1P-N 2"-SRW-011033009-101CH2S-N 2"-HGO-011013013-103CL2P-P 2"-NPH-011021023-101CH2S-P 3/4"-SRW-011021004-101CH2S-N 4"-SRW-011021004-101CH2S-N 3/4"-SRW-011021004-101CH2S-N 36"-VAC-011030002-101CH4S-P 3/4"-SRW-011021004-101CH2S-N 16"-VAC-011031001-101CH4S-H 3"-AMN-011099001-103CS2D-H 8"-NPH-011021002-103CH2S-N 12"-NPH-011021009-103CH2S-N
DS011-TRJR-480062 DS011-TRJR-480062 DS011-TRJR-480030 DS011-TRJR-480140 DS011-TRJR-480106 DS011-TRJR-480106 DS011-TRJR-480289 DS011-TRJR-480080 DS011-TRJR-480011 DS011-TRJR-480289 DS011-TRJR-480289 DS011-TRJR-480289 DS011-TRJR-480289 DS011-TRJR-480050 DS011-TRJR-480274 DS011-TRJR-480019 DS011-TRJR-480019 DS011-TRJR-480225 DS011-TRJR-480001 DS011-TRJR-480010 DS011-TRJR-480010 DS011-TRJR-480112 DS011-TRJR-480060 DS011-TRJR-480091 DS011-TRJR-480091 DS011-TRJR-480091 DS011-TRJR-480091 DS011-TRJR-480085 DS011-TRJR-480067 DS011-TRJR-480067 DS011-TRJR-480112 DS011-TRJR-480112 DS011-TRJR-480274 DS011-TRJR-480032 DS011-TRJR-480032 DS011-TRJR-480033 DS011-TRJR-480033 DS011-TRJR-480104 DS011-TRJR-480104 DS011-TRJR-480106 DS011-TRJR-480031 DS011-TRJR-480031 DS011-TRJR-480017 DS011-TRJR-480141 DS011-TRJR-480017 DS011-TRJR-480017 DS011-TRJR-480097 DS011-TRJR-480097 DS011-TRJR-480086 DS011-TRJR-480141 DS011-TRJR-480050 DS011-TRJR-480050 DS011-TRJR-480050 DS011-TRJR-480050 DS011-TRJR-480082 DS011-TRJR-480050 DS011-TRJR-480082 DS011-TRJR-480137 DS011-TRJR-480051 DS011-TRJR-480051
HAGO HAGO TOPPED CRUDE TOTAL NAPHTHA LP STEAM LP STEAM VENT GAS LVGO HC CLOSED DRAIN NITROGEN INSTRUMENT AIR AUXILIARY CW AUXILIARY CW NAPHTHA KERO DESALTED CRUDE CRUDE FLUSHING OIL DEMULSIFIER HAGO FRESH CRUDE WATER RECOVERED LVGO WATER SOUR OFF GAS AUXILIARY CW AUXILIARY CW VDU OFF GAS ATM. RESIDUE ATM. RESIDUE WATER WATER AMINE CLOSED DRAIN TOPPED CRUDE TOPPED CRUDE TOPPED CRUDE TOPPED CRUDE VACUUM RESIDUE VACUUM RESIDUE LP STEAM TOPPED CRUDE TOPPED CRUDE DESALTED CRUDE HEAVY GAS OIL DESALTED CRUDE HAGO LIGHT GAS OIL LVGO SOUR WATER HVGO NAPHTHA SOUR WATER SOUR WATER SOUR WATER VDU OFF GAS SOUR WATER VDU OFF GAS LEAN AMINE TOTAL NAPHTHA NAPHTHA
8"-NPH-011021010-103CH2S-N 16"-RES-011040006-103CS1P-S 2"-CRD-011016002-106CL2P-P 2"-CRD-011008003-103CS1P-P 2"-HGO-011013002-103CS1P-P 8"-FUG-011045302-101CS2P-S 2"-PIG-011045301-101CS1P-S 8"-HGO-011013002-103CS1P-S 16"-CRD-011008003-103CS1P-H 18"-LGO-011037001-103CS1P-H 10"-LGO-011037003-103CS1P-H 10"-LGO-011037009-103CS1P-H 2"-LGO-011037012-103CS1P-P 3/4"-LGO-011037012-103CS1P-P 18"-LGO-011037002-103CS1P-H 2"-LGO-011037013-103CS1P-P 2"-BRN-011007011-106CS2P-H 2"-HGO-011008003-103CS1P-S 2"-CRD-011008010-103CS1P-P 2"-WAT-011052011-101CS2P-P 1"-INA-011035301-301CG2P-N 2"-KER-011004003-101CS1P-P 18"-HGO-011027005-103CL2P-H 20"-HGO-011027002-103CL2P-H 18"-HGO-011027003-103CL2P-H 20"-HGO-011027001-103CL2P-H 4"-VTG-011036004-101CH4S-S 4"-VTG-011036004-101CH4S-S 2"-HGO-011027001-103CL2P-H 2"-HGO-011027007-103CL2P-P 3/4"-HGO-011027007-103CL2P-P 2"-HGO-011027006-103CL2P-P 3/4"-HGO-011027006-103CL2P-P 12"-WAT-011052003-101CS2P-H 8"-HGO-011008001-103CS1P-S 6"-FUG-011049302-101CS2P-S 2"-PIG-011049301-101CS1P-S 2"-CRD-011004006-106CS1P-P 6"-LGO-011025003-103CS1P-N 8"-FUG-011046302-101CS2P-S 2"-PIG-011046301-101CS1P-S 6"-FUG-011048302-101CS2P-S 2"-PIG-011048301-101CS1P-S 3/4"-LGO-011023013-103CS1P-P 2"-LGO-011023013-103CS1P-P 3/4"-LGO-011023012-103CS1P-P 2"-LGO-011023012-103CS1P-P 2"-SLP-011098004-103CS1P-N 6"-SLP-011098002-103CS1P-N 1"-RES-011027007-103CL4P-S 12"-NPH-011019002-101CH2S-P 8"-NPH-011019014-101CH2S-P 8"-NPH-011019003-101CH2S-P 12"-NPH-011019013-101CH2S-P 3/4"-LGO-011025013-101CS1P-P 2"-WAT-011052016-101CS2P-P 12"-WAT-011052014-101CS2P-H 16"-WAT-011052013-101CS2P-H 2"-NPH-011019018-101CH2S-P 6"-WST-011098002-101CS2P-N
DS011-TRJR-480051 DS011-TRJR-480138 DS011-TRJR-480030 DS011-TRJR-480016 DS011-TRJR-480016 DS011-TRJR-480115 DS011-TRJR-480115 DS011-TRJR-480016 DS011-TRJR-480016 DS011-TRJR-480096 DS011-TRJR-480096 DS011-TRJR-480096 DS011-TRJR-480096 DS011-TRJR-480096 DS011-TRJR-480096 DS011-TRJR-480096 DS011-TRJR-480011 DS011-TRJR-480016 DS011-TRJR-480016 DS011-TRJR-480123 DS011-TRJR-480091 DS011-TRJR-480008 DS011-TRJR-480065 DS011-TRJR-480065 DS011-TRJR-480065 DS011-TRJR-480065 DS011-TRJR-480118 DS011-TRJR-480118 DS011-TRJR-480065 DS011-TRJR-480065 DS011-TRJR-480065 DS011-TRJR-480065 DS011-TRJR-480065 DS011-TRJR-480124 DS011-TRJR-480016 DS011-TRJR-480119 DS011-TRJR-480119 DS011-TRJR-480007 DS011-TRJR-480133 DS011-TRJR-480116 DS011-TRJR-480116 DS011-TRJR-480118 DS011-TRJR-480118 DS011-TRJR-480055 DS011-TRJR-480055 DS011-TRJR-480055 DS011-TRJR-480055 DS011-TRJR-480134 DS011-TRJR-480134 DS011-TRJR-480066 DS011-TRJR-480047 DS011-TRJR-480047 DS011-TRJR-480047 DS011-TRJR-480047 DS011-TRJR-480059 DS011-TRJR-480124 DS011-TRJR-480124 DS011-TRJR-480124 DS011-TRJR-480047 DS011-TRJR-480135
NAPHTHA VACUUM RESIDUE TOPPED CRUDE CRUDE HEAVY GAS OIL FUEL GAS PILOT GAS HVGO DESALTED CRUDE LVGO LVGO LVGO LVGO LVGO LVGO LVGO BRINE HVGO DESALTED CRUDE WATER INSTRUMENT AIR KERO HAGO HAGO HAGO HAGO SWEET OFF-GAS SWEET OFF-GAS HEAVY GAS OIL HAGO HAGO HAGO HAGO WATER HVGO FUEL GAS PILOT GAS FRESH CRUDE LAGO FUEL GAS PILOT GAS FUEL GAS PILOT GAS LAGO LAGO LAGO LAGO SLOP OIL SLOP OIL ATM. RESIDUE NAPHTHA NAPHTHA NAPHTHA NAPHTHA LAGO WATER WATER WATER NAPHTHA STRIPPED SOUR WATER
CDU/VDU UNIT (UNIT 011) BLIND LIST
CDU/VDU UNIT (UNIT 011) BLIND LIST
Line number
P&ID
Service
Line number
P&ID
Service
2"-CRD-011015004-106CL2P-P 2"-OSW-011011305-101CS1P-N 10"-RES-011010003-103CS1P-S 3"-AMN-011036004-103CH2S-P 2"-HGO-011099001-103CS1P-S 2"-RES-011099001-103CS1P-S 6"-HGO-011024007-103CL2P-H 2"-HGO-011099002-103CS1P-S 8"-HGO-011038005-103CS1P-S 4"-VTG-011036005-101CH4S-S 2"-KER-011004004-101CS1P-P 2"-RES-011099002-103CS1P-S 3/4"-NPH-011019016-101CH2S-P 2"-NPH-011019016-101CH2S-P 2"-NPH-011019017-101CH2S-P 12"-HGO-011024005-103CL2P-H 4"-VTG-011036005-101CH4S-S 12"-HGO-011024004-103CL2P-H 2"-HGO-011098009-103CL2P-P 2"-HGO-011098010-103CL2P-P 14"-HGO-011098001-103CL2P-H 14"-HGO-011027003-103CL2P-H 12"-HGO-011039003-103CL2P-S 2"-HGO-011008001-103CS1P-P 2"-KER-011098002-103CS1P-P 2"-RES-011027008-103CL4P-S 1"-RES-011027008-103CL4P-S 2"-RES-011027007-103CL4P-S 2"-LGO-011098011-103CS1P-P 6"-LGO-011025002-103CS1P-N 2"-LGO-011098004-103CS1P-N 12"-CRD-011015004-106CL2P-H 2"-CRD-011015009-106CS2P-P 2"-HGO-011015005-103CL2P-S 2"-WAT-011052015-101CS2P-P 16"-LGO-011098001-103CS1P-H 12"-CRD-011014003-106CS2P-H 12"-HGO-011015003-103CL2P-S 16"-WAT-011052012-101CS2P-H 12"-NPH-011021001-103CH2S-N 2"-SLP-011098011-103CS1P-S 2"-SLP-011098005-103CS1P-S 2"-CRD-011015014-106CL2P-P 2"-WAT-011052009-101CS2P-P 26"-NPH-011011001-101CH2S-P 6"-NPH-011012002-101CH2S-P 2"-WAT-011052018-101CS2P-N 16"-CRD-011008001-103CS1P-H 12"-CRD-011011005-101CS1P-H 30"-CRD-011010005-101CH2S-H 6"-MPS-011011002-101CS1P-H 2"-CRD-011015013-106CL2P-P 2"-RES-011015005-103CL4P-S 12"-CRD-011015004-106CL2P-H 10"-RES-011015003-103CL4P-S 2"-CRD-011015007-106CL2P-P 2"-LGO-011098007-103CS1P-P 2"-LGO-011098006-103CS1P-P 2"-RES-011027012-103CL4P-S 2"-RES-011039003-103CL4P-P
DS011-TRJR-480028 DS011-TRJR-480142 DS011-TRJR-480137 DS011-TRJR-480137 DS011-TRJR-480137 DS011-TRJR-480137 DS011-TRJR-480057 DS011-TRJR-480138 DS011-TRJR-480138 DS011-TRJR-480119 DS011-TRJR-480008 DS011-TRJR-480138 DS011-TRJR-480047 DS011-TRJR-480047 DS011-TRJR-480047 DS011-TRJR-480057 DS011-TRJR-480119 DS011-TRJR-480057 DS011-TRJR-480134 DS011-TRJR-480134 DS011-TRJR-480134 DS011-TRJR-480134 DS011-TRJR-480028 DS011-TRJR-480100 DS011-TRJR-480135 DS011-TRJR-480066 DS011-TRJR-480066 DS011-TRJR-480066 DS011-TRJR-480140 DS011-TRJR-480133 DS011-TRJR-480133 DS011-TRJR-480028 DS011-TRJR-480028 DS011-TRJR-480028 DS011-TRJR-480124 DS011-TRJR-480140 DS011-TRJR-480028 DS011-TRJR-480028 DS011-TRJR-480124 DS011-TRJR-480051 DS011-TRJR-480136 DS011-TRJR-480136 DS011-TRJR-480029 DS011-TRJR-480122 DS011-TRJR-480020 DS011-TRJR-480020 DS011-TRJR-480122 DS011-TRJR-480016 DS011-TRJR-480020 DS011-TRJR-480020 DS011-TRJR-480020 DS011-TRJR-480029 DS011-TRJR-480029 DS011-TRJR-480029 DS011-TRJR-480029 DS011-TRJR-480029 DS011-TRJR-480140 DS011-TRJR-480140 DS011-TRJR-480066 DS011-TRJR-480029
CRUDE WATER VACUUM RESIDUE RICH AMINE HVGO VACUUM RESIDUE HAGO HVGO HVGO SWEET OFF-GAS KERO VACUUM RESIDUE NAPHTHA NAPHTHA NAPHTHA HAGO SWEET OFF-GAS HAGO HAGO HAGO HAGO HAGO HVGO HEAVY GAS OIL KERO ATM. RESIDUE ATM. RESIDUE ATM. RESIDUE LAGO LAGO LAGO TOPPED CRUDE TOPPED CRUDE HVGO WATER LAGO TOPPED CRUDE HVGO WATER TOTAL NAPHTHA SLOP OIL SLOP OIL TOPPED CRUDE WATER WET NAPHTHA NAPHTHA WATER DESALTED CRUDE TOPPED CRUDE DESALTED CRUDE MP STEAM TOPPED CRUDE VACUUM RESIDUE TOPPED CRUDE VACUUM RESIDUE CRUDE LAGO LAGO ATM. RESIDUE RESIDUE
3/4"-NPH-011019017-101CH2S-P 12"-RES-011027003-103CL4P-S 2"-CRD-011015011-106CL2P-P 2"-NPH-011098004-103CH2S-N 8"-NPH-011021002-103CH2S-N 16"-LGO-011010001-103CS1P-H 2"-BDH-011040004-101CS1P-P 2"-CRD-011015007-106CL2P-P 10"-RES-011039003-103CL4P-S 2"-LGO-011098005-103CS1P-N 8"-KER-011025002-103CS1P-N 2"-KER-011098003-103CS1P-N 12"-RES-011039003-103CL4P-S 2"-CRD-011013007-106CS1P-P 2"-SRW-011019012-101CH2S-P 18"-CRD-011098001-103CS1P-N 2"-CRD-011098003-103CS1P-N 2"-CRD-011098001-103CS1P-N 3/4"-NPH-011019030-101CH2S-N 12"-CRD-011015004-106CL2P-H 18"-LGO-011026003-103CS2P-H 2"-HGO-011015007-103CL2P-S 12"-HGO-011015003-103CL2P-S 12"-CRD-011014003-106CS2P-H 4"-LPF-011079301-101CH2F-S 2"-HGO-011015008-103CL2P-S 2"-CRD-011015010-106CS2P-P 2"-CRD-011015004-106CL2P-P 12"-HGO-011039003-103CL2P-S 2"-AMN-011036001-101CH2S-P 2"-AMN-011036001-101CH2S-P 2"-CRD-011013005-106CS1P-P 3"-AMN-011036006-101CH4S-H 12"-CRD-011013002-106CS1P-H 4"-VTG-011036001-101CH4S-N 12"-CRD-011013002-106CS1P-H 2"-CRD-011013006-106CS1P-P 2"-HGO-011013008-103CL2P-S 12"-HGO-011013003-103CL2P-S 8"-SRW-011044002-106CH2S-P 3"-NPH-011098002-103CH2S-P 2"-HGO-011013022-103CL2P-P 2"-KER-011018003-101CS1P-P 6"-BRN-011042003-101CS4P-N 2"-BRN-011098001-101CS4P-N 2"-LGO-011098003-103CS1P-N 3/4"-OIL-011033013-103CH2S-N 2"-OIL-011033013-103CH2S-N 2"-HGO-011098007-103CS1P-N 3/4"-WST-011098003-101CS2P-N 10"-RES-011039003-103CL4P-S 12"-CRD-011015007-106CL2P-H 12"-CRD-011015007-106CL2P-H 6"-LGO-011037007-103CS1P-N 2"-NPH-011098007-103CH2S-P 2"-RES-011028005-103CL4P-S 2"-SWA-011040302-101CS1P-N 1"-INH-011054001-101SC1P-N 1"-CHP-011054001-101SC1P-N 6"-CRD-011011006-106CS1P-P
DS011-TRJR-480047 DS011-TRJR-480066 DS011-TRJR-480028 DS011-TRJR-480140 DS011-TRJR-480140 DS011-TRJR-480140 DS011-TRJR-480105 DS011-TRJR-480029 DS011-TRJR-480029 DS011-TRJR-480133 DS011-TRJR-480133 DS011-TRJR-480133 DS011-TRJR-480103 DS011-TRJR-480025 DS011-TRJR-480046 DS011-TRJR-480133 DS011-TRJR-480133 DS011-TRJR-480133 DS011-TRJR-480046 DS011-TRJR-480028 DS011-TRJR-480018 DS011-TRJR-480028 DS011-TRJR-480028 DS011-TRJR-480028 DS011-TRJR-480233 DS011-TRJR-480028 DS011-TRJR-480028 DS011-TRJR-480028 DS011-TRJR-480028 DS011-TRJR-480094 DS011-TRJR-480094 DS011-TRJR-480025 DS011-TRJR-480094 DS011-TRJR-480025 DS011-TRJR-480094 DS011-TRJR-480025 DS011-TRJR-480025 DS011-TRJR-480025 DS011-TRJR-480025 DS011-TRJR-480132 DS011-TRJR-480020 DS011-TRJR-480025 DS011-TRJR-480043 DS011-TRJR-480132 DS011-TRJR-480132 DS011-TRJR-480132 DS011-TRJR-480087 DS011-TRJR-480087 DS011-TRJR-480132 DS011-TRJR-480135 DS011-TRJR-480029 DS011-TRJR-480029 DS011-TRJR-480029 DS011-TRJR-480132 DS011-TRJR-480135 DS011-TRJR-480069 DS011-TRJR-480105 DS011-TRJR-480020 DS011-TRJR-480020 DS011-TRJR-480020
NAPHTHA ATM. RESIDUE TOPPED CRUDE TOTAL NAPHTHA TOTAL NAPHTHA LAGO WATER CRUDE VACUUM RESIDUE LAGO KERO KERO VACUUM RESIDUE TOPPED CRUDE SOUR WATER FRESH CRUDE FRESH CRUDE CRUDE NAPHTHA TOPPED CRUDE LAGO HVGO HVGO TOPPED CRUDE FUEL GAS HVGO TOPPED CRUDE CRUDE HVGO RICH AMINE RICH AMINE TOPPED CRUDE LEAN AMINE TOPPED CRUDE SOUR OFF GAS TOPPED CRUDE TOPPED CRUDE HVGO HVGO SOUR WATER HEAVY NAPHTHA HVGO KERO BRINE BRINE LVGO RECOVERED LVGO RECOVERED LVGO HAGO STRIPPED SOUR WATER VACUUM RESIDUE TOPPED CRUDE TOPPED CRUDE LVGO HEAVY NAPHTHA ATM. RESIDUE SERVICE WATER CORROSION INHIBITOR NEUTRALIZING AGENT TOPPED CRUDE
CDU/VDU UNIT (UNIT 011) BLIND LIST
CDU/VDU UNIT (UNIT 011) BLIND LIST
Line number
P&ID
Service
Line number
P&ID
Service
2"-OIL-011033023-101CH2S-P 2"-OIL-011033018-101CH2S-N 3/4"-OIL-011033010-101CH2S-N 2"-OIL-011033010-101CH2S-N 1-1/2"-PRW-011043015-106CS2P-P 2"-SRW-011033016-106CH2S-N 3/4"-SRW-011033016-106CH2S-N 6"-SRW-011033014-106CH2S-N 2"-SRW-011033015-106CH2S-N 8"-SRW-011033006-106CH2S-N 3/4"-SRW-011033015-106CH2S-N 6"-SRW-011033002-106CH2S-N 8"-SRW-011033005-106CH2S-N 3/4"-OIL-011033014-103CH2S-N 2"-OIL-011033014-103CH2S-N 2"-SRW-011034014-106CH2S-N 2"-OIL-011033015-103CH2S-N 2"-OIL-011033016-103CH2S-N 2"-OIL-011033011-103CH2S-N 3/4"-CRD-011011006-106CS1P-P 2"-RES-011028006-103CL4P-S 3"-OIL-011033004-103CH2S-N 2"-OIL-011033002-103CH2S-N 3"-OIL-011033005-103CH2S-N 2"-OIL-011033012-103CH2S-N 14"-HGO-011013003-103CL2P-S 3/4"-NPH-011011001-101CH2S-P 3/4"-NPH-011011001-101CH2S-P 3/4"-NPH-011011001-101CH2S-P 4"-MPS-011011301-103CS1P-H 2"-VTG-011033002-101CH4S-N 12"-HGO-011013003-103CL2P-S 2"-HGO-011013007-103CL2P-S 12"-HGO-011015003-103CL2P-S 3/4"-NPH-011018002-101CH2S-P 2"-HGO-011015003-103CL2P-P 2"-MPC-011028305-103CS1P-H 12"-HGO-011015003-103CL2P-S 2"-HGO-011098008-103CS1P-N 2"-NPH-011011001-101CH2S-P 2"-CRD-011014006-106CS1P-P 2"-RES-011040010-103CS1P-S 3/4"-OSW-011040302-101CS1P-N 2"-LGO-011030005-101CS1P-S 3/4"-CRD-011001012-106CS1P-N 2"-CRD-011001012-106CS1P-N 18"-CRD-011001003-106CS1P-N 16"-CRD-011001006-106CS1P-H 16"-CRD-011001016-106CS1P-N 16"-CRD-011001006-106CS1P-H 2"-CRD-011001013-106CS1P-N 3/4"-CRD-011001013-106CS1P-N 20"-CRD-011001007-106CS1P-H 18"-CRD-011001004-106CS1P-N 20"-CRD-011001006-106CS1P-H 16"-CRD-011001005-106CS1P-N 16"-CRD-011001005-106CS1P-N 2"-CRD-011001011-106CS1P-N 2"-CRD-011001003-106CS1P-N 2"-HGO-011030004-101CL2P-S
DS011-TRJR-480086 DS011-TRJR-480086 DS011-TRJR-480086 DS011-TRJR-480086 DS011-TRJR-480111 DS011-TRJR-480088 DS011-TRJR-480088 DS011-TRJR-480088 DS011-TRJR-480088 DS011-TRJR-480088 DS011-TRJR-480088 DS011-TRJR-480088 DS011-TRJR-480088 DS011-TRJR-480087 DS011-TRJR-480087 DS011-TRJR-480090 DS011-TRJR-480087 DS011-TRJR-480087 DS011-TRJR-480087 DS011-TRJR-480020 DS011-TRJR-480069 DS011-TRJR-480087 DS011-TRJR-480087 DS011-TRJR-480087 DS011-TRJR-480087 DS011-TRJR-480141 DS011-TRJR-480020 DS011-TRJR-480020 DS011-TRJR-480020 DS011-TRJR-480020 DS011-TRJR-480086 DS011-TRJR-480025 DS011-TRJR-480025 DS011-TRJR-480025 DS011-TRJR-480043 DS011-TRJR-480025 DS011-TRJR-480139 DS011-TRJR-480025 DS011-TRJR-480132 DS011-TRJR-480020 DS011-TRJR-480027 DS011-TRJR-480104 DS011-TRJR-480104 DS011-TRJR-480080 DS011-TRJR-480002 DS011-TRJR-480002 DS011-TRJR-480002 DS011-TRJR-480003 DS011-TRJR-480002 DS011-TRJR-480003 DS011-TRJR-480002 DS011-TRJR-480002 DS011-TRJR-480003 DS011-TRJR-480002 DS011-TRJR-480003 DS011-TRJR-480003 DS011-TRJR-480003 DS011-TRJR-480002 DS011-TRJR-480002 DS011-TRJR-480080
RECOVERED LVGO RECOVERED LVGO RECOVERED LVGO RECOVERED LVGO WATER SOUR WATER SOUR WATER SOUR WATER SOUR WATER SOUR WATER SOUR WATER SOUR WATER SOUR WATER RECOVERED LVGO RECOVERED LVGO SOUR WATER RECOVERED LVGO RECOVERED LVGO RECOVERED LVGO TOPPED CRUDE ATM. RESIDUE RECOVERED LVGO RECOVERED LVGO RECOVERED LVGO RECOVERED LVGO HVGO WET NAPHTHA WET NAPHTHA WET NAPHTHA MP STEAM SOUR OFF GAS HVGO HVGO HVGO HEAVY NAPHTHA HEAVY GAS OIL MP CONDENSATE HVGO HAGO WET NAPHTHA TOPPED CRUDE VACUUM RESIDUE WATER LVGO FRESH CRUDE FRESH CRUDE FRESH CRUDE FRESH CRUDE FRESH CRUDE FRESH CRUDE FRESH CRUDE FRESH CRUDE FRESH CRUDE FRESH CRUDE FRESH CRUDE FRESH CRUDE FRESH CRUDE FRESH CRUDE CRUDE MVGO
2"-LGO-011023009-101CS2P-P 2"-RES-011040003-103CS1P-P 3/4"-OSW-011040304-101CS1P-N 12"-LPS-011040003-101CS1P-H 10"-RES-011040003-103CS1P-S 2"-RES-011040012-103CS1P-S 10"-RES-011040006-103CS1P-S 2"-RES-011040002-103CS1P-P 2"-LGO-011023007-101CS1P-P 3/4"-LGO-011023007-101CS1P-P 2"-RES-011040009-103CH2S-S 2"-CRD-011001004-106CS1P-N 2"-RES-011040008-103CH2S-S 2"-RES-011040011-103CS1P-S 3/4"-OSW-011040303-101CS1P-N 2"-CRD-011001010-106CS1P-N 3/4"-NPH-011019006-101CH2S-P 12"-RES-011027003-103CL4P-S 18"-RES-011027001-103CL4P-S 1-1/2"-PRW-011043014-106CS2P-P 4"-MPS-011030301-103CS1P-H 2"-SRW-011036006-101CH4S-N 6"-RES-011030002-101CL4P-S 1"-SRW-011036007-101CH4S-N 2"-SRW-011036007-101CH4S-N 3/4"-RES-011030003-101CL4P-S 4"-RES-011030003-101CL4P-S 3/4"-NPH-011019006-101CH2S-P 4"-LPS-011011301-101CS1P-P 3/4"-NPH-011019006-101CH2S-P 3/4"-NPH-011019006-101CH2S-P 2"-HGO-011013011-103CL2P-S 2"-VAC-011030003-101CH4S-P 10"-RES-011040001-103CS1P-S 12"-LPS-011040002-101CS1P-H 3/4"-LPS-011040013-101CS1P-H 6"-BFW-011040001-101CS1P-H 2"-SRW-011036009-101CH4S-P 2"-RES-011040005-103CS1P-P 14"-HGO-011013004-103SD0P-S 2"-HGO-011013010-103SD0P-P 2"-HGO-011013003-103CL2P-P 14"-HGO-011013003-103CL2P-S 2"-HGO-011013009-103SD0P-P 3/4"-HGO-011013009-103SD0P-P 2"-SRW-011033023-101CH2S-P 3/4"-SRW-011033013-101CH2S-N 3"-SRW-011033013-101CH2S-N 2"-LGO-011030003-103CS1P-N 2"-HGO-011013015-103CL2P-S 3/4"-SRW-011033012-101CH2S-N 2"-SRW-011033012-101CH2S-N 3"-SRW-011033022-101CH2S-N 2"-LGO-011200001-103CS1P-N 2"-HGO-011013014-103CL2P-P 3"-NPH-011098001-103CH2S-P 8"-KER-011025001-103CS1P-H 14"-HGO-011013005-103SD0P-S 2"-RES-011030009-101CM2P-P 16"-RES-011039001-103CL4P-S
DS011-TRJR-480054 DS011-TRJR-480104 DS011-TRJR-480104 DS011-TRJR-480104 DS011-TRJR-480104 DS011-TRJR-480104 DS011-TRJR-480104 DS011-TRJR-480104 DS011-TRJR-480054 DS011-TRJR-480054 DS011-TRJR-480104 DS011-TRJR-480002 DS011-TRJR-480104 DS011-TRJR-480104 DS011-TRJR-480104 DS011-TRJR-480002 DS011-TRJR-480046 DS011-TRJR-480066 DS011-TRJR-480066 DS011-TRJR-480111 DS011-TRJR-480081 DS011-TRJR-480093 DS011-TRJR-480081 DS011-TRJR-480093 DS011-TRJR-480093 DS011-TRJR-480081 DS011-TRJR-480081 DS011-TRJR-480046 DS011-TRJR-480142 DS011-TRJR-480046 DS011-TRJR-480046 DS011-TRJR-480024 DS011-TRJR-480080 DS011-TRJR-480104 DS011-TRJR-480104 DS011-TRJR-480104 DS011-TRJR-480104 DS011-TRJR-480093 DS011-TRJR-480104 DS011-TRJR-480141 DS011-TRJR-480141 DS011-TRJR-480141 DS011-TRJR-480141 DS011-TRJR-480141 DS011-TRJR-480141 DS011-TRJR-480086 DS011-TRJR-480086 DS011-TRJR-480086 DS011-TRJR-480080 DS011-TRJR-480141 DS011-TRJR-480086 DS011-TRJR-480086 DS011-TRJR-480086 DS011-TRJR-480274 DS011-TRJR-480141 DS011-TRJR-480135 DS011-TRJR-480135 DS011-TRJR-480141 DS011-TRJR-480081 DS011-TRJR-480103
LAGO RESIDUE WATER LP STEAM VACUUM RESIDUE VACUUM RESIDUE VACUUM RESIDUE RESIDUE LAGO LAGO VACUUM RESIDUE CRUDE VACUUM RESIDUE VACUUM RESIDUE WATER FRESH CRUDE NAPHTHA ATM. RESIDUE ATM. RESIDUE WATER MP STEAM SOUR WATER VACUUM RESIDUE SOUR WATER SOUR WATER VACUUM RESIDUE VACUUM RESIDUE NAPHTHA LP STEAM NAPHTHA NAPHTHA HVGO VDU OFF GAS VACUUM RESIDUE LP STEAM LP STEAM BOILER FEED WATER SOUR WATER RESIDUE HVGO HVGO HEAVY GAS OIL HVGO HVGO HEAVY GAS OIL SOUR WATER SOUR WATER SOUR WATER LVGO HVGO SOUR WATER SOUR WATER SOUR WATER LVGO HVGO HEAVY NAPHTHA KERO HVGO RESIDUE VACUUM RESIDUE
CDU/VDU UNIT (UNIT 011) BLIND LIST
CDU/VDU UNIT (UNIT 011) BLIND LIST
Line number
P&ID
Service
Line number
P&ID
Service
2"-SRW-011033020-101CH2S-N 2"-RES-011040001-103CS1P-P 10"-RES-011040003-103CS1P-S 6"-BFW-011040002-101CS1P-H 2"-AMN-011036018-103CH2S-P 10"-RES-011015003-103CL4P-S 6"-SRW-011044003-106CH2S-P 6"-SRW-011044004-106CH2S-P 3/4"-SRW-011044008-106CH2S-P 2"-SRW-011044008-106CH2S-P 3/4"-SRW-011044009-106CH2S-P 2"-SRW-011044009-106CH2S-P 2"-SRW-011036003-101CH4S-N 6"-HGO-011039018-103SD0P-S 6"-HGO-011039004-103CL2P-S 6"-HGO-011039019-103SD0P-S 2"-HGO-011039016-103SD0P-S 2"-PRW-011043018-101CS2P-P 2"-CRD-011014003-106CS2P-P 2"-HGO-011038001-103CL2P-P 2"-HGO-011038013-103CL2P-S 3/4"-HGO-011038013-103CL2P-S 2"-HGO-011038012-103CL2P-S 6"-VTG-011034003-101CH4S-N 3/4"-HGO-011039011-103CL2P-S 2"-HGO-011039011-103CL2P-S 3/4"-HGO-011039012-103CL2P-S 2"-HGO-011039012-103CL2P-S 6"-LPF-011078301-101CH2F-N 2"-HGO-011038002-103CL2P-P 6"-HGO-011039013-103CL2P-S 2"-HGO-011039013-103CL2P-P 2"-HGO-011039017-103CL2P-S 3/4"-HGO-011039015-103SD0P-S 2"-BDH-011040005-101CS1P-P 2"-BRN-011042006-101CS4P-N 3/4"-BRN-011042006-101CS4P-N 12"-CRD-011014003-106CS2P-H 12"-CRD-011014003-106CS2P-H 3/4"-AMN-011036016-103CH2S-P 2"-AMN-011036016-103CH2S-P 3"-AMN-011036011-103CH2S-P 3"-AMN-011036004-103CH2S-P 3"-AMN-011036015-103CH2S-P 2"-AMN-011036017-103CH2S-P 3/4"-AMN-011036017-103CH2S-P 3"-AMN-011036014-103CH2S-P 3/4"-HGO-011030007-101SD0P-S 2"-HGO-011030007-101SD0P-S 2"-HGO-011039015-103SD0P-S 2"-HGO-011039001-103CL2P-P 2"-CRD-011018001-101CL4P-P 16"-NPH-011003001-101CH2S-P 16"-NPH-011003001-101CH2S-P 2"-NPH-011003003-101CH2S-P 12"-CRD-011002002-106CS1P-H 2"-CRD-011003005-106CS1P-P 2"-RES-011039004-103CL4P-P 12"-RES-011039003-103CL4P-S 2"-RES-011039002-103CL4P-P
DS011-TRJR-480086 DS011-TRJR-480104 DS011-TRJR-480104 DS011-TRJR-480104 DS011-TRJR-480095 DS011-TRJR-480027 DS011-TRJR-480114 DS011-TRJR-480114 DS011-TRJR-480114 DS011-TRJR-480114 DS011-TRJR-480114 DS011-TRJR-480114 DS011-TRJR-480093 DS011-TRJR-480102 DS011-TRJR-480102 DS011-TRJR-480102 DS011-TRJR-480102 DS011-TRJR-480112 DS011-TRJR-480027 DS011-TRJR-480099 DS011-TRJR-480099 DS011-TRJR-480099 DS011-TRJR-480099 DS011-TRJR-480090 DS011-TRJR-480101 DS011-TRJR-480101 DS011-TRJR-480101 DS011-TRJR-480101 DS011-TRJR-480232 DS011-TRJR-480099 DS011-TRJR-480102 DS011-TRJR-480102 DS011-TRJR-480102 DS011-TRJR-480102 DS011-TRJR-480105 DS011-TRJR-480109 DS011-TRJR-480109 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480095 DS011-TRJR-480095 DS011-TRJR-480095 DS011-TRJR-480095 DS011-TRJR-480095 DS011-TRJR-480095 DS011-TRJR-480095 DS011-TRJR-480095 DS011-TRJR-480081 DS011-TRJR-480081 DS011-TRJR-480102 DS011-TRJR-480101 DS011-TRJR-480044 DS011-TRJR-480005 DS011-TRJR-480005 DS011-TRJR-480005 DS011-TRJR-480005 DS011-TRJR-480005 DS011-TRJR-480103 DS011-TRJR-480103 DS011-TRJR-480103
SOUR WATER RESIDUE VACUUM RESIDUE BOILER FEED WATER RICH AMINE VACUUM RESIDUE SOUR WATER SOUR WATER SOUR WATER SOUR WATER SOUR WATER SOUR WATER SOUR WATER HVGO HVGO HVGO HVGO LP STEAM CRUDE HEAVY GAS OIL MVGO MVGO MVGO SOUR OFF GAS HVGO HVGO HEAVY GAS OIL HVGO FUEL GAS HEAVY GAS OIL HVGO HEAVY GAS OIL HVGO HEAVY GAS OIL WATER BRINE BRINE TOPPED CRUDE TOPPED CRUDE AMINE RICH AMINE RICH AMINE RICH AMINE RICH AMINE RICH AMINE AMINE RICH AMINE HVGO HVGO HVGO HEAVY GAS OIL CRUDE WET NAPHTHA WET NAPHTHA WET NAPHTHA FRESH CRUDE FRESH CRUDE RESIDUE VACUUM RESIDUE RESIDUE
2"-RES-011039001-103CL4P-P 4"-RES-011030001-103CL4P-P 20"-CRD-011011002-106CS1P-H 2"-SRW-011034005-101CH2S-N 2"-HGO-011005006-103CL2P-P 2"-HGO-011005007-103CL2P-P 20"-CRD-011008011-103CS1P-H 3/4"-NPH-011012003-101CH2S-P 2"-CRD-011003002-106CS1P-P 3/4"-NPH-011012003-101CH2S-P 24"-NPH-011003001-101CH2S-P 2"-SRW-011012001-101CH2S-P 8"-NPH-011012001-101CH2S-P 2"-DWA-011034302-101SR0P-N 12"-LGO-011023004-103CS1P-H 6"-LGO-011023006-103CS1P-H 12"-LGO-011023005-103CS1P-H 6"-LGO-011023014-103CS1P-H 2"-CRD-011011010-106CS1P-P 16"-CRD-011008001-103CS1P-H 1"-INH-011054002-101SC1P-N 20"-CRD-011008012-103CS1P-H 16"-CRD-011008013-103CS1P-H 12"-CRD-011003002-106CS1P-H 2"-HGO-011039014-103SD0P-S 2"-HGO-011022002-103CL2P-P 10"-HGO-011022002-103CL2P-H 2"-HGO-011022002-103CL2P-P 10"-HGO-011022002-103CL2P-H 2"-HGO-011014005-103CL2P-P 2"-HGO-011009001-103CL2P-P 2"-CRD-011008009-103CS1P-P 3/4"-CRD-011008009-103CS1P-P 2"-CRD-011005002-106CS1P-P 2"-CRD-011005005-106CS1P-P 2"-CRD-011011002-106CS1P-P 6"-VTG-011034004-101CH4S-S 3/4"-BRN-011007007-106CS2P-P 2"-BRN-011007006-106CS2P-P 3/4"-BRN-011007006-106CS2P-P 2"-BRN-011007007-106CS2P-P 6"-BRN-011007002-106CS2P-H 10"-HGO-011014002-103CL2P-H 2"-PWA-011073301-301PU0W-N 3/4"-SRW-011034005-101CH2S-N 2"-CRD-011011003-106CS1P-P 40"-CWS-011072301-301FE0W-N 40"-CWR-011072301-301FE0W-N 2"-CRD-011014005-106CS1P-P 2"-CRD-011014004-106CS1P-P 10"-HGO-011014002-103CL2P-H 2"-HGO-011014004-103CL2P-P 1"-VTG-011036011-101CH4S-S 4"-VTG-011036003-101CH4S-S 2"-AMN-011036009-101CH4S-P 3/4"-OSW-011036308-101CS1P-N 6"-VTG-011036004-101CH4S-S 4"-VTG-011036003-101CH4S-P 16"-HGO-011039010-103CL2P-S 2"-CRD-011005002-106CS1P-N
DS011-TRJR-480103 DS011-TRJR-480103 DS011-TRJR-480021 DS011-TRJR-480089 DS011-TRJR-480010 DS011-TRJR-480010 DS011-TRJR-480015 DS011-TRJR-480023 DS011-TRJR-480005 DS011-TRJR-480023 DS011-TRJR-480023 DS011-TRJR-480023 DS011-TRJR-480023 DS011-TRJR-480089 DS011-TRJR-480055 DS011-TRJR-480055 DS011-TRJR-480055 DS011-TRJR-480055 DS011-TRJR-480021 DS011-TRJR-480015 DS011-TRJR-480043 DS011-TRJR-480015 DS011-TRJR-480015 DS011-TRJR-480005 DS011-TRJR-480102 DS011-TRJR-480026 DS011-TRJR-480026 DS011-TRJR-480026 DS011-TRJR-480026 DS011-TRJR-480026 DS011-TRJR-480010 DS011-TRJR-480015 DS011-TRJR-480015 DS011-TRJR-480010 DS011-TRJR-480010 DS011-TRJR-480021 DS011-TRJR-480089 DS011-TRJR-480013 DS011-TRJR-480013 DS011-TRJR-480013 DS011-TRJR-480013 DS011-TRJR-480013 DS011-TRJR-480026 DS011-TRJR-480209 DS011-TRJR-480089 DS011-TRJR-480021 DS011-TRJR-480207 DS011-TRJR-480207 DS011-TRJR-480026 DS011-TRJR-480026 DS011-TRJR-480026 DS011-TRJR-480026 DS011-TRJR-480094 DS011-TRJR-480094 DS011-TRJR-480094 DS011-TRJR-480094 DS011-TRJR-480094 DS011-TRJR-480094 DS011-TRJR-480101 DS011-TRJR-480010
RESIDUE RESIDUE TOPPED CRUDE SOUR WATER HAGO HAGO DESALTED CRUDE NAPHTHA CRUDE NAPHTHA WET NAPHTHA SOUR WATER NAPHTHA DEMINERALIZED WATER LAGO LAGO LAGO LAGO TOPPED CRUDE DESALTED CRUDE CORROSION INHIBITOR DESALTED CRUDE DESALTED CRUDE FRESH CRUDE HVGO HEAVY GAS OIL HAGO HEAVY GAS OIL HAGO HAGO HEAVY GAS OIL DESALTED CRUDE DESALTED CRUDE CRUDE FRESH CRUDE CRUDE SOUR OFF GAS BRINE BRINE BRINE BRINE BRINE HAGO POTABLE WATER SOUR WATER CRUDE SOFT CW SOFT CW TOPPED CRUDE TOPPED CRUDE HAGO HAGO SWEET OFF-GAS SWEET OFF-GAS RICH AMINE WATER SWEET OFF-GAS SWEET OFF-GAS HVGO CRUDE
CDU/VDU UNIT (UNIT 011) BLIND LIST
CDU/VDU UNIT (UNIT 011) BLIND LIST
Line number
P&ID
Service
Line number
P&ID
Service
3"-AMN-011036022-101CH4S-P 3/4"-OSW-011040308-101CS1P-N 2"-VTG-011034003-101CH4S-N 2"-RES-011039007-103CL4P-S 3/4"-RES-011039007-103CL4P-S 3/4"-RES-011039008-103CL4P-S 2"-RES-011039008-103CL4P-S 1"-VTG-011034007-101CH4S-S 2"-VTG-011036007-101CH4S-P 2"-SRW-011034013-101CH2S-P 6"-VTG-011034001-101CH4S-S 2"-HGO-011014008-103CL2P-P 3/4"-SRW-011033302-101CH2S-N 1"-SRW-011033301-101CH4S-N 3"-INA-011074301-301CG2P-N 3"-LPN-011074301-101CS1P-N 3"-UTA-011074301-301CG2P-N 2"-LGO-011037020-103CS1P-N 8"-HGO-011025003-103CS1P-N 8"-HGO-011098006-103CS1P-N 6"-WST-011098001-101CS2P-N 2"-SWA-011073302-301FE0W-N 6"-BRN-011007005-106CS2P-H 8"-BRN-011007001-106CS2P-H 2"-HGO-011039002-103CL2P-P 1"-VTG-011033002-101CH4S-N 1"-VTG-011033002-101CH4S-N 3/4"-HGO-011030010-101CL2P-P 16"-HGO-011039003-103CL2P-S 20"-HGO-011039002-103CL2P-S 20"-HGO-011039001-103CL2P-S 2"-CRD-011003002-106CS1P-P 12"-CRD-011003002-106CS1P-H 8"-HGO-011038004-103CS1P-S 16"-CRD-011011011-106CS1P-H 2"-HGO-011038004-103CS1P-P 2"-AMN-011036002-103CS2D-P 4"-LPS-011024001-101CS1P-P 3/4"-CRD-011011009-106CS1P-P 2"-CRD-011011008-106CS1P-P 3/4"-CRD-011011008-106CS1P-P 2"-CRD-011011009-106CS1P-P 6"-HGO-011009001-103CL2P-H 6"-HGO-011009001-103CL2P-H 2"-AMN-011036007-103CS2D-P 3/4"-NPH-011018002-101CH2S-P 4"-LPS-011023001-101CS1P-H 2"-OSW-011034301-101CS1P-N 6"-HGO-011005004-103CL2P-H 12"-CRD-011005002-106CS1P-H 2"-AMN-011036023-101CH4S-P 12"-CRD-011005001-106CS1P-H 12"-CRD-011005002-106CS1P-H 2"-LGO-011037017-103CS1P-N 2"-NPH-011003002-101CH2S-P 2"-CRD-011003004-106CS1P-P 12"-CRD-011002002-106CS1P-H 4"-SRW-011032001-101CH4S-N 2"-SRW-011032003-101CH4S-N 3"-SRW-011032002-101CH4S-N
DS011-TRJR-480094 DS011-TRJR-480104 DS011-TRJR-480090 DS011-TRJR-480103 DS011-TRJR-480103 DS011-TRJR-480103 DS011-TRJR-480103 DS011-TRJR-480090 DS011-TRJR-480094 DS011-TRJR-480090 DS011-TRJR-480090 DS011-TRJR-480026 DS011-TRJR-480086 DS011-TRJR-480086 DS011-TRJR-480211 DS011-TRJR-480211 DS011-TRJR-480211 DS011-TRJR-480098 DS011-TRJR-480132 DS011-TRJR-480132 DS011-TRJR-480132 DS011-TRJR-480209 DS011-TRJR-480013 DS011-TRJR-480013 DS011-TRJR-480101 DS011-TRJR-480086 DS011-TRJR-480086 DS011-TRJR-480080 DS011-TRJR-480101 DS011-TRJR-480101 DS011-TRJR-480101 DS011-TRJR-480005 DS011-TRJR-480005 DS011-TRJR-480137 DS011-TRJR-480021 DS011-TRJR-480100 DS011-TRJR-480094 DS011-TRJR-480056 DS011-TRJR-480021 DS011-TRJR-480021 DS011-TRJR-480021 DS011-TRJR-480021 DS011-TRJR-480010 DS011-TRJR-480010 DS011-TRJR-480094 DS011-TRJR-480043 DS011-TRJR-480054 DS011-TRJR-480089 DS011-TRJR-480010 DS011-TRJR-480010 DS011-TRJR-480094 DS011-TRJR-480010 DS011-TRJR-480010 DS011-TRJR-480098 DS011-TRJR-480005 DS011-TRJR-480005 DS011-TRJR-480005 DS011-TRJR-480086 DS011-TRJR-480086 DS011-TRJR-480086
RICH AMINE WATER SOUR OFF GAS VACUUM RESIDUE RESIDUE RESIDUE VACUUM RESIDUE SOUR OFF GAS SWEET OFF-GAS SOUR WATER SOUR OFF GAS HAGO SOUR WATER SOUR WATER INSTRUMENT AIR NITROGEN SERVICE AIR LVGO HAGO HAGO STRIPPED SOUR WATER SERVICE WATER BRINE BRINE HEAVY GAS OIL SOUR OFF GAS SOUR OFF GAS MVGO HVGO HVGO HVGO CRUDE FRESH CRUDE HVGO TOPPED CRUDE HEAVY GAS OIL LEAN AMINE LP STEAM TOPPED CRUDE TOPPED CRUDE TOPPED CRUDE TOPPED CRUDE HAGO HAGO LEAN AMINE HEAVY NAPHTHA LP STEAM WATER HAGO FRESH CRUDE RICH AMINE FRESH CRUDE FRESH CRUDE LVGO WET NAPHTHA FRESH CRUDE FRESH CRUDE SOUR WATER SOUR WATER SOUR WATER
2"-SRW-011034001-101CH2S-N 2"-SRW-011012004-101CH2S-P 3/4"-SRW-011012004-101CH2S-P 3/4"-SRW-011012004-101CH2S-P 2"-NPH-011012010-101CH2S-P 2"-CRD-011005004-106CS1P-P 2"-SRW-011034003-101CH2S-N 2"-SRW-011034012-101CH2S-P 2"-RES-011014009-103CL2P-S 2"-CRD-011014008-106CS1P-P 2"-RES-011014007-103CL2P-S 10"-RES-011014002-103CL2P-S 3"-SLP-011076012-103CH2S-H 32"-LPF-011076301-101CH2F-N 32"-LPF-011076301-101CH2F-N 2"-NPH-011002009-101CH2S-P 2"-CLD-011078334-101CH2S-P 4"-SLP-011078001-103CH2S-P 2"-FUG-011075305-101CS2P-S 12"-FUG-011075301-101CS2P-H 10"-RES-011014002-103CL2P-S 6"-RES-011014003-103CL2P-S 1/2"-CHP-011053401-101CS1P-N 2"-RES-011014003-103CL2P-P 1/2"-CHP-011053401-101CS1P-N 2"-RES-011014006-103CL4P-S 1/2"-CHP-011053411-101CS1P-N 1/2"-CHP-011053411-101CS1P-N 4"-SLP-011076010-101CH2S-P 2"-RES-011014008-103CL2P-S 2"-SLP-011076009-101CH2S-P 2"-CRD-011003011-106CS1P-P 44"-LPF-011076001-101CH2F-N 10"-SLP-011076003-103CH2S-P 3"-HGO-011024010-101CL2P-H 3/4"-HGO-011024014-103CL2P-P 2"-HGO-011024016-101CL2P-P 3"-NPH-011098001-103CH2S-P 2"-HGO-011024014-103CL2P-P 2"-HGO-011024018-101CL2P-P 3/4"-HGO-011024014-103CL2P-P 2"-HGO-011014003-103CL2P-P 10"-HGO-011014007-101CL2P-H 10"-HGO-011014007-101CL2P-H 10"-HGO-011018002-101CL2P-H 12"-LPS-011018001-101CL4P-H 12"-LPS-011018001-101CL4P-H 10"-SLP-011076002-101CH2S-P 3/4"-SLP-011076007-103CH2S-P 2"-SLP-011076007-103CH2S-P 6"-SLP-011076006-103CH2S-P 6"-SLP-011076001-103CH2S-P 6"-LPF-011078301-101CH2F-N 6"-RES-011014004-101CL2P-S 24"-LPS-011041006-101CS1P-H 24"-LPS-011041006-101CS1P-H 2"-HGO-011014006-103CL2P-P 2"-NPH-011002004-101CH2S-P 3/4"-LPF-011076302-101CH2F-N 2"-FUG-011075304-101CS2P-N
DS011-TRJR-480086 DS011-TRJR-480023 DS011-TRJR-480023 DS011-TRJR-480023 DS011-TRJR-480023 DS011-TRJR-480010 DS011-TRJR-480089 DS011-TRJR-480089 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480219 DS011-TRJR-480219 DS011-TRJR-480219 DS011-TRJR-480004 DS011-TRJR-480232 DS011-TRJR-480232 DS011-TRJR-480214 DS011-TRJR-480214 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480125 DS011-TRJR-480027 DS011-TRJR-480125 DS011-TRJR-480027 DS011-TRJR-480125 DS011-TRJR-480125 DS011-TRJR-480219 DS011-TRJR-480027 DS011-TRJR-480219 DS011-TRJR-480005 DS011-TRJR-480219 DS011-TRJR-480219 DS011-TRJR-480056 DS011-TRJR-480056 DS011-TRJR-480056 DS011-TRJR-480043 DS011-TRJR-480056 DS011-TRJR-480056 DS011-TRJR-480056 DS011-TRJR-480026 DS011-TRJR-480044 DS011-TRJR-480044 DS011-TRJR-480044 DS011-TRJR-480044 DS011-TRJR-480044 DS011-TRJR-480219 DS011-TRJR-480219 DS011-TRJR-480219 DS011-TRJR-480219 DS011-TRJR-480219 DS011-TRJR-480232 DS011-TRJR-480081 DS011-TRJR-480081 DS011-TRJR-480081 DS011-TRJR-480026 DS011-TRJR-480004 DS011-TRJR-480219 DS011-TRJR-480214
SOUR WATER NAPHTHA NAPHTHA NAPHTHA NAPHTHA FRESH CRUDE SOUR WATER SOUR WATER VACUUM RESIDUE TOPPED CRUDE VACUUM RESIDUE VACUUM RESIDUE SLOP OIL FUEL GAS FUEL GAS HEAVY NAPHTHA HC CLOSED DRAIN SLOP OIL FUEL GAS FUEL GAS VACUUM RESIDUE VACUUM RESIDUE DEMULSIFIER RESIDUE DEMULSIFIER VACUUM RESIDUE DEMULSIFIER DEMULSIFIER SLOP OIL VACUUM RESIDUE SLOP OIL FRESH CRUDE FUEL GAS SLOP OIL HAGO HAGO HAGO HEAVY NAPHTHA HAGO HAGO HAGO HAGO HAGO HAGO HAGO LP STEAM LP STEAM SLOP OIL SLOP OIL SLOP OIL SLOP OIL SLOP OIL FUEL GAS VACUUM RESIDUE LP STEAM LP STEAM HAGO HEAVY NAPHTHA FUEL GAS FUEL GAS
CDU/VDU UNIT (UNIT 011) BLIND LIST
CDU/VDU UNIT (UNIT 011) BLIND LIST
Line number
P&ID
Service
Line number
P&ID
Service
2"-PIG-011075303-101CS1P-S 3/4"-FUG-011200301-101CS2P-S 2"-SWA-011040301-101CS1P-N 4"-VTG-011035001-101CH4S-P 6"-VTG-011034002-101CH4S-S 2"-VTG-011034014-101CH4S-S 10"-SLP-011076004-103CH2S-P 2"-SLP-011076008-103CH2S-P 3/4"-SLP-011076008-103CH2S-P 2"-CRD-011015025-106CS2P-P 2"-HGO-011015009-103CL2P-P 6"-PRW-011042006-106CS2P-H 2"-CRD-011003006-106CS1P-P 1"-CHP-011053003-106SC1P-N 3/4"-CRD-011008008-103CS1P-P 2"-CRD-011008008-103CS1P-P 8"-BRN-011007004-106CS2P-H 6"-CLD-011078301-101CH2S-N 3/4"-FUG-011075305-101CS2P-S 3"-BRN-011006301-103CS4P-H 3/4"-FUG-011075310-101CS2P-N 2"-HGO-011038015-103CS1P-S 2"-FUG-011075308-101CS2P-N 2"-HGO-011038016-103CS1P-S 2"-FUG-011075307-101CS2P-N 24"-HGO-011030001-101CL2P-S 24"-HGO-011030001-101CL2P-S 20"-NPH-011012004-101CH2S-P 18"-LGO-011010001-103CS1P-H 6"-HGO-011038007-103CL2P-S 6"-HGO-011038003-103CL2P-S 16"-CRD-011001005-106CS1P-N 2"-AMD-011079002-103CH2S-P 2"-AMD-011079003-103CH2S-P 4"-LPS-011024002-101CS1P-P 12"-HGO-011024013-101CL2P-H 2"-LPS-011024016-101CS1P-P 4"-LPS-011011301-101CS1P-P 4"-LPS-011011303-101CS1P-P 2"-RES-011015008-103CL4P-S 2"-CRD-011015016-106CL2P-P 2"-RES-011015006-103CL4P-S 2"-RES-011015007-103CL4P-S 2"-CRD-011015015-106CL2P-P 10"-RES-011015003-103CL4P-S 12"-CRD-011015004-106CL2P-H 2"-HGO-011009001-103CL2P-P 4"-OSW-011021304-101CS1P-N 10"-NPH-011020002-101CH2S-N 2"-RES-011039003-103CL4P-P 2"-HGO-011009005-103CL2P-P 18"-CRD-011005002-106CS1P-H 2"-CRD-011008011-103CS1P-P 3/4"-SLP-011076009-101CH2S-P 1"-LPF-011035306-101CH2F-N 2"-NPH-011012019-101CH2S-P 2"-NPH-011012003-101CH2S-P 2"-CLD-011078325-101CH2S-N 2"-CLD-011078326-101CH2S-N 2"-CLD-011078324-101CH2S-N
DS011-TRJR-480214 DS011-TRJR-480274 DS011-TRJR-480105 DS011-TRJR-480091 DS011-TRJR-480091 DS011-TRJR-480091 DS011-TRJR-480219 DS011-TRJR-480219 DS011-TRJR-480219 DS011-TRJR-480028 DS011-TRJR-480028 DS011-TRJR-480013 DS011-TRJR-480005 DS011-TRJR-480013 DS011-TRJR-480015 DS011-TRJR-480015 DS011-TRJR-480013 DS011-TRJR-480232 DS011-TRJR-480214 DS011-TRJR-480011 DS011-TRJR-480214 DS011-TRJR-480100 DS011-TRJR-480214 DS011-TRJR-480100 DS011-TRJR-480214 DS011-TRJR-480081 DS011-TRJR-480081 DS011-TRJR-480023 DS011-TRJR-480018 DS011-TRJR-480099 DS011-TRJR-480099 DS011-TRJR-480002 DS011-TRJR-480233 DS011-TRJR-480233 DS011-TRJR-480056 DS011-TRJR-480056 DS011-TRJR-480056 DS011-TRJR-480142 DS011-TRJR-480142 DS011-TRJR-480029 DS011-TRJR-480029 DS011-TRJR-480029 DS011-TRJR-480029 DS011-TRJR-480029 DS011-TRJR-480029 DS011-TRJR-480029 DS011-TRJR-480010 DS011-TRJR-480050 DS011-TRJR-480050 DS011-TRJR-480029 DS011-TRJR-480017 DS011-TRJR-480011 DS011-TRJR-480015 DS011-TRJR-480219 DS011-TRJR-480091 DS011-TRJR-480023 DS011-TRJR-480023 DS011-TRJR-480229 DS011-TRJR-480229 DS011-TRJR-480231
PILOT GAS FUEL GAS SERVICE WATER SOUR OFF GAS SOUR OFF GAS NITROGEN SLOP OIL SLOP OIL SLOP OIL TOPPED CRUDE HVGO WATER FRESH CRUDE DEMULSIFIER DESALTED CRUDE DESALTED CRUDE BRINE HC CLOSED DRAIN FUEL GAS BRINE FUEL GAS HVGO FUEL GAS HVGO FUEL GAS HVGO HVGO NAPHTHA LAGO MVGO MVGO FRESH CRUDE AMINE CLOSED DRAIN AMINE CLOSED DRAIN LP STEAM HAGO LP STEAM LP STEAM LP STEAM VACUUM RESIDUE TOPPED CRUDE VACUUM RESIDUE VACUUM RESIDUE TOPPED CRUDE VACUUM RESIDUE TOPPED CRUDE HEAVY GAS OIL WATER NAPHTHA RESIDUE HAGO FRESH CRUDE CRUDE SLOP OIL FUEL GAS NAPHTHA NAPHTHA HC CLOSED DRAIN HC CLOSED DRAIN HC CLOSED DRAIN
12"-KER-011004001-101CS1P-H 12"-KER-011004001-101CS1P-H 16"-KER-011022002-101CS1P-H 2"-SRW-011200003-106CH2S-P 2"-HGO-011014009-103CL2P-P 2"-CLD-011078327-101CH2S-N 2"-LPS-011011304-101CS1P-P 16"-SLP-011098001-103CS1P-S 2"-HGO-011013023-103CL2P-P 1"-CHP-011054002-101SC1P-N 1"-CHP-011054001-101SC1P-N 2"-HGO-011014010-103CL2P-P 3/4"-RES-011030008-101CM2P-S 2"-CRD-011015028-106CL2P-P 6"-HGO-011024006-103CL2P-H 1"-INH-011054421-101SC1P-N 2"-SRW-011036002-101CH4S-N 4"-VTG-011035002-101CH4S-N 1"-VTG-011034012-101CH4S-N 2"-FLO-011002301-101CS1P-N 2"-FLO-011002302-101CS1P-N 2"-LGO-011018005-103CS2P-P 2"-HGO-011018003-103CL2P-P 12"-HGO-011024002-101CL2P-H 2"-HGO-011015003-103CL2P-P 3/4"-NPH-011200002-101CH2S-P 2"-LGO-011018004-103CS1P-P 2"-FUG-011075305-101CS2P-N 2"-RES-011018002-103CL4P-S 4"-MPS-011018301-103CS1P-H 2"-KER-011018002-101CS1P-P 2"-CRD-011003010-106CS1P-P 2"-OSW-011044304-101CS1P-N 2"-SRW-011044005-101CH2S-P 2"-SRW-011044014-101CH2S-P 1"-CLD-011007310-103CS4P-P 2"-CRD-011018004-101CL4P-P 2"-RES-011015009-103CL4P-P 2"-CRD-011015027-106CL2P-P 2"-HGO-011018007-101CL2P-P 2"-LGO-011018008-101CS2P-P 2"-NPH-011012010-101CH2S-P 2"-SRW-011034008-101CH2S-N 3/4"-SRW-011034008-101CH2S-N 28"-LGO-011018001-101CS2P-H 28"-LGO-011018001-101CS2P-H 10"-HGO-011024002-101CL2P-H 10"-HGO-011024002-101CL2P-H 28"-HGO-011018001-101CL2P-H 28"-HGO-011018001-101CL2P-H 8"-RES-011027014-101CL4P-S 8"-LGO-011018002-101CS2P-H 18"-CRD-011007002-103CS1P-H 3/4"-HGO-011030009-101SD0P-S 2"-OSW-011051301-101CS1P-N 2"-SRW-011044016-106CH2S-P 2"-BRN-011007011-106CS2P-H 4"-CLD-011006309-103CS4P-P 6"-BRN-011006001-103CS4P-P 3"-NPH-011019008-101CH2S-P
DS011-TRJR-480043 DS011-TRJR-480043 DS011-TRJR-480043 DS011-TRJR-480274 DS011-TRJR-480026 DS011-TRJR-480228 DS011-TRJR-480142 DS011-TRJR-480136 DS011-TRJR-480025 DS011-TRJR-480126 DS011-TRJR-480126 DS011-TRJR-480026 DS011-TRJR-480081 DS011-TRJR-480029 DS011-TRJR-480057 DS011-TRJR-480127 DS011-TRJR-480093 DS011-TRJR-480093 DS011-TRJR-480090 DS011-TRJR-480004 DS011-TRJR-480004 DS011-TRJR-480044 DS011-TRJR-480044 DS011-TRJR-480056 DS011-TRJR-480025 DS011-TRJR-480274 DS011-TRJR-480043 DS011-TRJR-480214 DS011-TRJR-480044 DS011-TRJR-480044 DS011-TRJR-480043 DS011-TRJR-480005 DS011-TRJR-480113 DS011-TRJR-480113 DS011-TRJR-480113 DS011-TRJR-480012 DS011-TRJR-480044 DS011-TRJR-480029 DS011-TRJR-480029 DS011-TRJR-480044 DS011-TRJR-480044 DS011-TRJR-480023 DS011-TRJR-480090 DS011-TRJR-480090 DS011-TRJR-480044 DS011-TRJR-480044 DS011-TRJR-480044 DS011-TRJR-480044 DS011-TRJR-480044 DS011-TRJR-480044 DS011-TRJR-480044 DS011-TRJR-480044 DS011-TRJR-480012 DS011-TRJR-480081 DS011-TRJR-480121 DS011-TRJR-480114 DS011-TRJR-480011 DS011-TRJR-480011 DS011-TRJR-480011 DS011-TRJR-480043
KERO KERO KERO SOUR WATER HAGO HC CLOSED DRAIN LP STEAM SLOP OIL HVGO NEUTRALIZING AGENT NEUTRALIZING AGENT HC CLOSED DRAIN RESIDUE TOPPED CRUDE HAGO CORROSION INHIBITOR SOUR WATER SOUR OFF GAS SOUR OFF GAS FLUSHING OIL FLUSHING OIL LAGO HAGO HAGO HEAVY GAS OIL NAPHTHA LAGO FUEL GAS ATM. RESIDUE MP STEAM KERO FRESH CRUDE WATER SOUR WATER SOUR WATER HC CLOSED DRAIN TOPPED CRUDE VACUUM RESIDUE TOPPED CRUDE HAGO LAGO NAPHTHA SOUR WATER SOUR WATER LAGO LAGO HAGO HAGO HAGO HAGO ATM. RESIDUE LAGO DESALTED CRUDE HVGO WATER SOUR WATER BRINE HC CLOSED DRAIN BRINE NAPHTHA
CDU/VDU UNIT (UNIT 011) BLIND LIST
CDU/VDU UNIT (UNIT 011) BLIND LIST
Line number
P&ID
Service
Line number
P&ID
Service
1"-CHP-011054002-101SC1P-N 2"-NPH-011018003-101CH2S-P 6"-VTG-011032001-101CH4S-P 2"-SRW-011034004-101CH2S-N 18"-CRD-011006006-103CS1P-H 2"-CRD-011006005-106CS1P-P 3/4"-NPH-011018002-101CH2S-P 3/4"-NPH-011018002-101CH2S-P 3/4"-NPH-011018002-101CH2S-P 3/4"-NPH-011018002-101CH2S-P 3/4"-NPH-011018002-101CH2S-P 3/4"-NPH-011018002-101CH2S-P 2"-WAT-011052017-101CS2P-P 2"-KER-011004008-101CS1P-P 2"-RES-011010011-103CL2P-P 2"-LPS-011017013-101CS1P-P 4"-LPS-011017008-101CS1P-P 4"-LPS-011017001-101CS1P-H 1"-CHP-011054003-101SC1P-N 8"-RES-011030009-101CM2P-S 6"-HGO-011039008-101SD0P-S 2"-RES-011039005-101CL4P-S 6"-SRW-011019001-101CH2S-P 4"-SRW-011021001-101CH2S-N 6"-SRW-011044001-101CH2S-P 4"-NPH-011019004-101CH2S-P 1"-CHP-011053003-106SC1P-N 1"-CHP-011053001-103SC1P-N 3/4"-HGO-011025011-103CS1P-P 2"-CRD-011015026-106CS2P-P 2"-HGO-011015010-106CS2P-P 4"-VTG-011035007-101CH4S-S 2"-LPN-011035301-101CS1P-N 4"-VTG-011035007-101CH4S-P 4"-LPS-011023002-101CS1P-P 4"-LPS-011023001-101CS1P-P 2"-LPS-011023010-101CS1P-P 3/4"-SLP-011001002-103CS1P-N 3/4"-SLP-011001002-103CS1P-N 16"-CRD-011006001-106CS1P-H 2"-CLD-011078330-101CH2S-P 2"-CRD-011013008-106CS1P-P 24"-CRD-011011012-101CS1P-H 2"-SWA-011041301-101CS1P-N 6"-MPS-011011002-101CS1P-H 16"-CRD-011011004-106CS1P-H 4"-LPC-011071303-101CS1P-H 3/4"-FUG-011075306-101CS2P-S 2"-LPC-011071001-101CS1P-P 12"-FUG-011075302-101CS2P-S 3"-CLD-011006309-103CS4P-P 4"-LPS-011071002-101CS1P-P 6"-LPC-011071003-101CS1P-H 4"-LPC-011071002-101CS1P-H 3"-CLD-011006309-103CS4P-P 3/4"-CRD-011006014-103CS1P-P 1"-CLD-011006310-103CS4P-P 3"-CLD-011006309-103CS4P-P 2"-BRN-011007011-106CS2P-H 3"-CLD-011006309-103CS4P-P
DS011-TRJR-480043 DS011-TRJR-480043 DS011-TRJR-480089 DS011-TRJR-480089 DS011-TRJR-480011 DS011-TRJR-480010 DS011-TRJR-480043 DS011-TRJR-480043 DS011-TRJR-480043 DS011-TRJR-480043 DS011-TRJR-480043 DS011-TRJR-480043 DS011-TRJR-480122 DS011-TRJR-480008 DS011-TRJR-480019 DS011-TRJR-480042 DS011-TRJR-480042 DS011-TRJR-480042 DS011-TRJR-480126 DS011-TRJR-480081 DS011-TRJR-480081 DS011-TRJR-480081 DS011-TRJR-480113 DS011-TRJR-480113 DS011-TRJR-480113 DS011-TRJR-480113 DS011-TRJR-480125 DS011-TRJR-480125 DS011-TRJR-480061 DS011-TRJR-480028 DS011-TRJR-480028 DS011-TRJR-480091 DS011-TRJR-480091 DS011-TRJR-480091 DS011-TRJR-480054 DS011-TRJR-480054 DS011-TRJR-480054 DS011-TRJR-480001 DS011-TRJR-480001 DS011-TRJR-480011 DS011-TRJR-480227 DS011-TRJR-480025 DS011-TRJR-480020 DS011-TRJR-480106 DS011-TRJR-480020 DS011-TRJR-480021 DS011-TRJR-480201 DS011-TRJR-480214 DS011-TRJR-480201 DS011-TRJR-480214 DS011-TRJR-480011 DS011-TRJR-480201 DS011-TRJR-480201 DS011-TRJR-480201 DS011-TRJR-480011 DS011-TRJR-480011 DS011-TRJR-480011 DS011-TRJR-480011 DS011-TRJR-480011 DS011-TRJR-480011
NEUTRALIZING AGENT NAPHTHA SOUR OFF GAS SOUR WATER FRESH CRUDE FRESH CRUDE HEAVY NAPHTHA HEAVY NAPHTHA HEAVY NAPHTHA HEAVY NAPHTHA HEAVY NAPHTHA HEAVY NAPHTHA WATER KERO FRESH CRUDE LP STEAM LP STEAM LOW PRESSURE STEAM NEUTRALIZING AGENT ATM. RESIDUE HVGO VACUUM RESIDUE SOUR WATER SOUR WATER SOUR WATER NAPHTHA DEMULSIFIER DEMULSIFIER HAGO TOPPED CRUDE HVGO SOUR OFF GAS NITROGEN SOUR OFF GAS LP STEAM LP STEAM LP STEAM SLOP OIL SLOP OIL FRESH CRUDE HC CLOSED DRAIN TOPPED CRUDE TOPPED CRUDE SERVICE WATER MP STEAM TOPPED CRUDE LP CONDENSATE FUEL GAS LP CONDENSATE FUEL GAS HC CLOSED DRAIN LP STEAM LP CONDENSATE LP CONDENSATE HC CLOSED DRAIN FRESH CRUDE HC CLOSED DRAIN HC CLOSED DRAIN BRINE HC CLOSED DRAIN
16"-KER-011022002-101CS1P-H 12"-KER-011022001-101CS1P-H 28"-KER-011022008-101CS1P-H 20"-KER-011022007-101CS1P-H 2"-CRD-011009005-103CS1P-P 2"-CRD-011009004-103CS1P-P 2"-LGO-011009002-103CS1P-P 2"-BRN-011007011-106CS2P-H 8"-MPS-011032001-103CS1P-H 8"-MPS-011032301-103CS1P-H 2"-MPS-011032302-103CS1P-H 2"-AMD-011079313-101CH2S-P 2"-CLD-011078323-101CH2S-N 10"-VTG-011052001-101CS2P-P 6"-WAT-011052006-101CS2P-N 10"-WAT-011052001-101CS2P-P 2"-SWA-011017301-101CS1P-N 2"-LGO-011023017-101CS1P-P 8"-SLP-011098003-103CS1P-S 2"-DWA-011079301-101SR0P-N 3"-AMD-011079301-101CH2S-P 2"-KER-011004007-101CS1P-P 2"-AMD-011079316-101CH2S-P 1"-RES-011030007-101CL4P-S 2"-AMD-011079005-103CH2S-P 2"-AMD-011079007-101CH2S-P 2"-AMD-011079007-101CH2S-P 2"-AMD-011079306-103CH2S-P 2"-AMD-011079002-103CH2S-P 2"-RES-011028008-103CL4P-S 2"-RES-011028007-103CL4P-S 14"-LGO-011023002-101CS1P-H 10"-LGO-011023001-101CS2P-H 12"-LGO-011023003-101CS1P-H 3"-OSW-011023304-101CS1P-N 6"-LPS-011023004-101CS1P-H 6"-LPS-011023004-101CS1P-H 2"-CLD-011078328-101CH2S-N 3/4"-CRD-011011006-106CS1P-P 3/4"-CRD-011011302-101CS1P-P 3/4"-CRD-011011301-101CS1P-P 6"-CRD-011011015-101CS1P-H 3/4"-NPH-011021005-101CH2S-N 3/4"-NPH-011021019-101CH2S-N 3/4"-NPH-011021018-101CH2S-N 4"-LPC-011071006-101CS1P-P 2"-DWA-011071302-101SR0P-N 6"-HPW-011071301-106CS1P-H 3"-CND-011071302-103CS1P-H 20"-LPS-011071301-101CS1P-H 12"-MPS-011071301-103CS1P-H 4"-HGO-011030001-101CL2P-P 3/4"-LGO-011023016-101CS1P-P 2"-NPH-011019022-101CH2S-P 2"-FLO-011077001-101CS1P-N 1"-AMN-011036009-101CH4S-P 1"-AMN-011036301-101CH4S-P 3/4"-NPH-011012016-101CH2S-P 3/4"-HGO-011018006-101CL2P-P 3/4"-LGO-011018009-101CS2P-P
DS011-TRJR-480052 DS011-TRJR-480052 DS011-TRJR-480052 DS011-TRJR-480052 DS011-TRJR-480017 DS011-TRJR-480017 DS011-TRJR-480017 DS011-TRJR-480011 DS011-TRJR-480084 DS011-TRJR-480084 DS011-TRJR-480084 DS011-TRJR-480233 DS011-TRJR-480230 DS011-TRJR-480122 DS011-TRJR-480122 DS011-TRJR-480122 DS011-TRJR-480042 DS011-TRJR-480054 DS011-TRJR-480136 DS011-TRJR-480233 DS011-TRJR-480233 DS011-TRJR-480008 DS011-TRJR-480233 DS011-TRJR-480081 DS011-TRJR-480233 DS011-TRJR-480233 DS011-TRJR-480233 DS011-TRJR-480233 DS011-TRJR-480233 DS011-TRJR-480070 DS011-TRJR-480070 DS011-TRJR-480054 DS011-TRJR-480054 DS011-TRJR-480054 DS011-TRJR-480054 DS011-TRJR-480054 DS011-TRJR-480054 DS011-TRJR-480226 DS011-TRJR-480020 DS011-TRJR-480020 DS011-TRJR-480020 DS011-TRJR-480020 DS011-TRJR-480050 DS011-TRJR-480050 DS011-TRJR-480050 DS011-TRJR-480201 DS011-TRJR-480202 DS011-TRJR-480202 DS011-TRJR-480202 DS011-TRJR-480202 DS011-TRJR-480202 DS011-TRJR-480101 DS011-TRJR-480054 DS011-TRJR-480045 DS011-TRJR-480225 DS011-TRJR-480094 DS011-TRJR-480094 DS011-TRJR-480023 DS011-TRJR-480044 DS011-TRJR-480044
KERO KERO KERO KERO DESALTED CRUDE DESALTED CRUDE LAGO BRINE MP STEAM MP STEAM MP STEAM AMINE CLOSED DRAIN HC CLOSED DRAIN AIR WATER WATER SERVICE WATER LAGO SLOP OIL DEMINERALIZED WATER AMINE CLOSED DRAIN KERO AMINE CLOSED DRAIN ATM. RESIDUE AMINE CLOSED DRAIN AMINE CLOSED DRAIN AMINE CLOSED DRAIN AMINE CLOSED DRAIN AMINE CLOSED DRAIN ATM. RESIDUE ATM. RESIDUE LAGO LAGO LAGO WATER LP STEAM LP STEAM HC CLOSED DRAIN TOPPED CRUDE TOPPED CRUDE TOPPED CRUDE TOPPED CRUDE NAPHTHA NAPHTHA NAPHTHA LP CONDENSATE DEMINERALIZED WATER BOILER FEED WATER PUMPED HOT CONDENSATE LP STEAM MP STEAM HEAVY GAS OIL LAGO HEAVY NAPHTHA FLUSHING OIL RICH AMINE RICH AMINE NAPHTHA HAGO LAGO
CDU/VDU UNIT (UNIT 011) BLIND LIST
CDU/VDU UNIT (UNIT 011) BLIND LIST
Line number
P&ID
Service
Line number
P&ID
Service
3/4"-NPH-011012017-101CH2S-P 2"-SRW-011012006-101CH2S-P 1"-VTG-011034013-101CH4S-N 1"-CRD-011018003-101CL4P-S 6"-SRW-011044002-106CH2S-P 6"-SRW-011044015-106CH2S-P 6"-RES-011018005-103CL4P-S 2"-RES-011010008-103CS1P-S 3/4"-KER-011018301-101CS1P-P 2"-HGO-011009004-103CL2P-P 2"-SWA-011024301-101CS1P-N 2"-LGO-011018003-101CS1P-P 6"-LPS-011071001-101CS1P-P 8"-AWS-011080302-301FE0W-N 8"-AWR-011080302-301FE0W-N 2"-LGO-011037021-103CS1P-P 2"-KER-011022020-101CS1P-H 4"-KER-011022021-101CS1P-H 3/4"-OSW-011040309-101CS1P-N 2"-LPS-011071001-101CS1P-P 2"-LPC-011071005-101CS1P-P 2"-LPC-011071004-101CS1P-H 2"-CRD-011010009-103CS1P-P 2"-CRD-011001022-106CS1P-N 2"-CRD-011001023-106CS1P-N 1"-VTG-011036008-101CH4S-N 2"-KER-011001002-103CS1P-P 2"-HGO-011001002-103CS1P-P 2"-KER-011004006-101CS1P-P 6"-NPH-011012006-101CH2S-P 8"-NPH-011012005-101CH2S-P 8"-NPH-011012001-101CH2S-P 6"-NPH-011012002-101CH2S-P 2"-LPS-011071416-101CS1P-P 3/4"-KER-011022023-103CS1P-P 8"-PRW-011043005-106CS2P-P 8"-PRW-011043004-106CS2P-P 6"-PRW-011043006-106CS2P-P 6"-PRW-011043006-106CS2P-P 2"-NPH-011012012-103CS1P-N 3"-SRW-011031003-101CH4S-N 3"-SRW-011031002-101CH4S-N 1"-CLD-011006309-103CS4P-P 4"-CLD-011006309-103CS4P-P 3/4"-CLD-011006303-103CH2S-P 2"-CLD-011006303-103CH2S-P 12"-KER-011022004-103CS1P-H 8"-KER-011022006-103CS1P-H 12"-KER-011022005-103CS1P-H 8"-KER-011022017-103CS1P-H 2"-CRD-011002008-106CS1P-N 2"-LPS-011078302-101CS1P-H 2"-KER-011004005-101CS1P-P 3/4"-NPH-011021024-101CH2S-S 2"-CRD-011004004-106CS1P-P 10"-NPH-011021005-101CH2S-N 3/4"-NPH-011021025-101CH2S-N 3/4"-CRD-011006003-103CS1P-H 3/4"-CRD-011006003-103CS1P-H 4"-CRD-011006003-103CS1P-H
DS011-TRJR-480023 DS011-TRJR-480023 DS011-TRJR-480089 DS011-TRJR-480044 DS011-TRJR-480114 DS011-TRJR-480114 DS011-TRJR-480044 DS011-TRJR-480019 DS011-TRJR-480043 DS011-TRJR-480017 DS011-TRJR-480056 DS011-TRJR-480043 DS011-TRJR-480201 DS011-TRJR-480237 DS011-TRJR-480237 DS011-TRJR-480097 DS011-TRJR-480052 DS011-TRJR-480052 DS011-TRJR-480104 DS011-TRJR-480201 DS011-TRJR-480201 DS011-TRJR-480201 DS011-TRJR-480019 DS011-TRJR-480003 DS011-TRJR-480003 DS011-TRJR-480093 DS011-TRJR-480003 DS011-TRJR-480003 DS011-TRJR-480008 DS011-TRJR-480022 DS011-TRJR-480022 DS011-TRJR-480022 DS011-TRJR-480022 DS011-TRJR-480201 DS011-TRJR-480052 DS011-TRJR-480111 DS011-TRJR-480111 DS011-TRJR-480111 DS011-TRJR-480111 DS011-TRJR-480022 DS011-TRJR-480086 DS011-TRJR-480086 DS011-TRJR-480011 DS011-TRJR-480011 DS011-TRJR-480011 DS011-TRJR-480011 DS011-TRJR-480053 DS011-TRJR-480053 DS011-TRJR-480053 DS011-TRJR-480053 DS011-TRJR-480004 DS011-TRJR-480232 DS011-TRJR-480008 DS011-TRJR-480050 DS011-TRJR-480008 DS011-TRJR-480050 DS011-TRJR-480050 DS011-TRJR-480011 DS011-TRJR-480011 DS011-TRJR-480011
NAPHTHA SOUR WATER SOUR OFF GAS TOPPED CRUDE SOUR WATER SOUR WATER ATM. RESIDUE VACUUM RESIDUE KERO HAGO SERVICE WATER LIGHT GAS OIL LP STEAM AUXILIARY CW AUXILIARY CW LVGO KERO KERO WATER LP STEAM LP CONDENSATE LP CONDENSATE DESALTED CRUDE FRESH CRUDE FRESH CRUDE SOUR OFF GAS KERO HAGO KERO NAPHTHA NAPHTHA NAPHTHA NAPHTHA LP CONDENSATE KERO WATER WATER WATER WATER NAPHTHA SOUR WATER SOUR WATER CLOSE DRAIN HC CLOSED DRAIN HC CLOSED DRAIN HC CLOSED DRAIN KERO KERO KERO KERO FRESH CRUDE LP STEAM KERO NAPHTHA FRESH CRUDE NAPHTHA NAPHTHA FRESH CRUDE FRESH CRUDE FRESH CRUDE
3/4"-SRW-011044013-101CH2S-P 3/4"-SRW-011044005-101CH2S-P 3/4"-AMD-011079008-101CH2S-P 2"-RES-011010007-103CS1P-S 2"-LGO-011004002-103CS1P-P 2"-RES-011010010-103CL2P-S 2"-CRD-011010012-103CS1P-P 2"-CRD-011004003-106CS1P-P 2"-HGO-011008017-103CS1P-S 2"-CRD-011008020-103CS1P-P 2"-HGO-011008019-103CS1P-P 2"-CRD-011010010-103CS1P-P 2"-CRD-011010011-103CS1P-P 2"-RES-011010009-103CL2P-S 2"-CRD-011008018-103CS1P-P 2"-LPS-011078301-101CS1P-H 1"-BRN-011042008-101CS4P-P 2"-BRN-011042008-101CS4P-P 16"-NPH-011011001-101CH2S-P 16"-NPH-011011001-101CH2S-P 3"-BRN-011007302-103CS4P-H 3"-CRD-011007002-103CS1P-H 2"-CLD-011007305-103CH2S-P 3/4"-CLD-011007305-103CH2S-P 4"-CLD-011007309-103CS4P-P 1"-CLD-011007309-103CS4P-P 2"-SRW-011021009-101CH2S-N 2"-CRD-011007004-106CS1P-P 16"-CRD-011007006-106CS1P-H 4"-CRD-011007012-103CS1P-H 3"-CLD-011007309-103CS4P-P 3/4"-CRD-011007012-103CS1P-H 2"-FUG-011075001-101CS2P-P 12"-FUG-011075309-101CS2P-H 8"-RES-011030009-101CM2P-S 1/2"-CHP-011053406-106SC1P-N 1/2"-CHP-011053406-106SC1P-N 1/2"-CHP-011053407-106SC1P-N 1/2"-CHP-011053407-106SC1P-N 3"-CLD-011007309-103CS4P-P 3/4"-CRD-011007012-103CS1P-H 3"-CLD-011007309-103CS4P-P 4"-CLD-011007309-103CS4P-P 6"-BRN-011007013-103CS4P-P 2"-BRN-011007012-106CS2P-H 3"-CLD-011007309-103CS4P-P 2"-BRN-011007012-106CS2P-H 18"-CRD-011007019-103CS1P-H 2"-BRN-011007012-106CS2P-H 2"-BRN-011007012-106CS2P-H 2"-CLD-011007312-103CH2S-P 3"-CLD-011007309-103CS4P-P 3"-CLD-011007309-103CS4P-P 6"-BRN-011007013-103CS4P-P 4"-CLD-011007309-103CS4P-P 2"-BRN-011007012-106CS2P-H 2"-BRN-011007012-106CS2P-H 3/4"-OSW-011035303-101CS1P-N 2"-HGO-011039003-103CL2P-P 6"-BRN-011007002-106CS2P-H
DS011-TRJR-480113 DS011-TRJR-480113 DS011-TRJR-480233 DS011-TRJR-480019 DS011-TRJR-480007 DS011-TRJR-480019 DS011-TRJR-480019 DS011-TRJR-480008 DS011-TRJR-480016 DS011-TRJR-480016 DS011-TRJR-480016 DS011-TRJR-480019 DS011-TRJR-480019 DS011-TRJR-480019 DS011-TRJR-480016 DS011-TRJR-480232 DS011-TRJR-480108 DS011-TRJR-480108 DS011-TRJR-480005 DS011-TRJR-480005 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480050 DS011-TRJR-480013 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480214 DS011-TRJR-480214 DS011-TRJR-480081 DS011-TRJR-480125 DS011-TRJR-480125 DS011-TRJR-480125 DS011-TRJR-480125 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480091 DS011-TRJR-480028 DS011-TRJR-480010
SOUR WATER SOUR WATER AMINE CLOSED DRAIN VACUUM RESIDUE LAGO VACUUM RESIDUE DESALTED CRUDE FRESH CRUDE HVGO DESALTED CRUDE HVGO DESALTED CRUDE DESALTED CRUDE VACUUM RESIDUE DESALTED CRUDE LP STEAM BRINE BRINE WET NAPHTHA WET NAPHTHA BRINE CRUDE HC CLOSED DRAIN HC CLOSED DRAIN HC CLOSED DRAIN CLOSE DRAIN SOUR WATER FRESH CRUDE FRESH CRUDE FRESH CRUDE HC CLOSED DRAIN FRESH CRUDE FUEL GAS FUEL GAS ATM. RESIDUE DEMULSIFIER DEMULSIFIER DEMULSIFIER DEMULSIFIER HC CLOSED DRAIN FRESH CRUDE HC CLOSED DRAIN HC CLOSED DRAIN BRINE BRINE HC CLOSED DRAIN BRINE FRESH CRUDE BRINE BRINE HC CLOSED DRAIN HC CLOSED DRAIN HC CLOSED DRAIN BRINE HC CLOSED DRAIN BRINE BRINE WATER HEAVY GAS OIL BRINE
CDU/VDU UNIT (UNIT 011) BLIND LIST
CDU/VDU UNIT (UNIT 011) BLIND LIST
Line number
P&ID
Service
Line number
P&ID
Service
1"-CHP-011053002-106SC1P-N 4"-LPS-011041003-101CS1P-P 1"-RES-011030010-101CL4P-S 1"-RES-011030003-101CL4P-S 1"-VAC-011030003-101CH4S-P 1"-VAC-011030003-101CH4S-P 1"-VAC-011030003-101CH4S-P 1"-VAC-011030003-101CH4S-P 14"-LGO-011030001-101CS1P-H 10"-LGO-011030002-101CS1P-P 14"-LGO-011030001-101CS1P-H 6"-LGO-011037004-101CS1P-H 14"-HGO-011013006-101SD0P-S 8"-HGO-011030002-101CL2P-S 56"-VAC-011030001-101CH4S-P 56"-VAC-011030002-101CH4S-P 2"-CLD-011078329-101CH2S-N 1/2"-CHP-011054413-101CS1P-N 1/2"-CHP-011054412-101CS1P-N 2"-RES-011027005-103CL4P-P 3/4"-FLO-011200301-101CS1P-N 1/2"-CHP-011054413-101CS1P-N 1/2"-CHP-011054412-101CS1P-N 20"-CRD-011011003-106CS1P-H 24"-CRD-011007002-103CS1P-H 2"-AMD-011079308-103CH2S-P 3/4"-LPF-011007303-101CH2F-N 3"-BRN-011007301-103CS4P-H 6"-LPS-011040006-101CS1P-P 4"-LPS-011017007-101CS1P-P 2"-HGO-011027002-103CL2P-H 2"-HGO-011098015-103CS1P-N 3/4"-NPH-011019024-101CH2S-P 3"-BFW-011040302-101CS1P-P 10"-LPS-011040004-101CS1P-H 2"-BDH-011040002-101CS1P-P 2"-BDH-011040001-101CS1P-P 6"-BFW-011040002-101CS1P-H 6"-BFW-011040001-101CS1P-H 2"-FLO-011040307-101CS1P-N 4"-FUG-011075304-101CS2P-N 6"-LPS-011024004-101CS1P-H 6"-LPS-011024004-101CS1P-H 3/4"-HGO-011024014-103CL2P-P 3/4"-HGO-011024012-101CL2P-P 10"-HGO-011024015-101CL2P-H 3/4"-PIG-011075308-101CS1P-N 3"-MPS-011032002-103CS1P-H 3"-MPS-011032005-103CS1P-H 3"-MPS-011032006-103CS1P-H 2"-MPS-011032003-103CS1P-H 2"-MPS-011032007-103CS1P-H 2"-MPS-011032008-103CS1P-H 3"-MPS-011032004-103CS1P-H 3"-MPS-011032009-103CS1P-H 3"-MPS-011032010-103CS1P-H 2"-CRD-011008012-103CS1P-P 4"-FLO-011013308-101CS1P-N 2"-LPS-011071303-101CS1P-H 2"-LPS-011076303-101CS1P-H
DS011-TRJR-480010 DS011-TRJR-480106 DS011-TRJR-480081 DS011-TRJR-480081 DS011-TRJR-480080 DS011-TRJR-480080 DS011-TRJR-480080 DS011-TRJR-480080 DS011-TRJR-480080 DS011-TRJR-480080 DS011-TRJR-480080 DS011-TRJR-480080 DS011-TRJR-480080 DS011-TRJR-480080 DS011-TRJR-480080 DS011-TRJR-480080 DS011-TRJR-480226 DS011-TRJR-480126 DS011-TRJR-480126 DS011-TRJR-480066 DS011-TRJR-480275 DS011-TRJR-480126 DS011-TRJR-480126 DS011-TRJR-480021 DS011-TRJR-480012 DS011-TRJR-480233 DS011-TRJR-480012 DS011-TRJR-480012 DS011-TRJR-480105 DS011-TRJR-480042 DS011-TRJR-480065 DS011-TRJR-480132 DS011-TRJR-480046 DS011-TRJR-480105 DS011-TRJR-480105 DS011-TRJR-480105 DS011-TRJR-480105 DS011-TRJR-480105 DS011-TRJR-480105 DS011-TRJR-480104 DS011-TRJR-480214 DS011-TRJR-480056 DS011-TRJR-480056 DS011-TRJR-480056 DS011-TRJR-480056 DS011-TRJR-480056 DS011-TRJR-480214 DS011-TRJR-480084 DS011-TRJR-480084 DS011-TRJR-480084 DS011-TRJR-480084 DS011-TRJR-480084 DS011-TRJR-480084 DS011-TRJR-480084 DS011-TRJR-480084 DS011-TRJR-480084 DS011-TRJR-480015 DS011-TRJR-480141 DS011-TRJR-480202 DS011-TRJR-480219
DEMULSIFIER LP STEAM ATM. RESIDUE VACUUM RESIDUE VDU OFF GAS VDU OFF GAS VDU OFF GAS VDU OFF GAS LVGO LVGO LVGO LVGO HVGO MVGO VDU OFF GAS VDU OFF GAS HC CLOSED DRAIN NEUTRALIZING AGENT NEUTRALIZING AGENT RESIDUE FLUSHING OIL NEUTRALIZING AGENT NEUTRALIZING AGENT TOPPED CRUDE DESALTED CRUDE AMINE CLOSED DRAIN FUEL GAS BRINE LP STEAM LP STEAM HEAVY GAS OIL HAGO NAPHTHA BOILER FEED WATER LP STEAM WATER WATER BOILER FEED WATER BOILER FEED WATER FLUSHING OIL FUEL GAS LP STEAM LP STEAM HAGO HAGO HAGO PILOT GAS MP STEAM MP STEAM MP STEAM MP STEAM MP STEAM MP STEAM MP STEAM MP STEAM MP STEAM CRUDE FLUSHING OIL LP STEAM LP STEAM
2"-LPS-011076302-101CS1P-H 44"-LPF-011076001-101CH2F-N 6"-VTG-011034001-101CH4S-S 2"-SRW-011034002-101CH2S-N 2"-SRW-011034009-101CH2S-N 1"-INH-011054422-101SC1P-N 1"-LPF-011230302-101CH2F-N 1"-VTG-011230302-101CS1P-N 1"-CHP-011054003-101SC1P-N 1"-CHP-011054003-101SC1P-N 2"-AMD-011079309-103CH2S-P 3/4"-AMD-011079309-103CH2S-P 3/4"-AMD-011079306-103CH2S-P 3"-NPH-011021004-101CH2S-N 2"-HGO-011039003-103CL2P-P 12"-LGO-011018003-101CS1P-H 12"-LGO-011018003-101CS1P-H 8"-KER-011026002-101CS1P-H 6"-NPH-011019005-101CH2S-P 12"-NPH-011019001-101CH2S-P 4"-NPH-011019004-101CH2S-P 3/4"-VAC-011032022-101CH4S-P 3"-CRD-011006006-103CS1P-H 2"-RES-011015003-103CL4P-P 2"-RES-011015003-103CL4P-P 10"-RES-011015003-103CL4P-S 4"-VTG-011033001-101CH4S-N 2"-RES-011014010-103CL2P-P 2"-RES-011014011-103CL2P-P 2"-HGO-011098013-103CS1P-P 8"-MPS-011028002-103CS1P-H 18"-CRD-011006006-103CS1P-H 2"-RES-011027001-103CL4P-P 12"-RES-011027006-103CL4P-S 18"-RES-011027002-103CL4P-S 2"-RES-011027002-103CL4P-P 3/4"-NPH-011019027-101CH2S-P 1"-VTG-011230303-101CS1P-N 1"-LPN-011230303-101CS1P-N 1"-INA-011230303-301CG2P-N 4"-SRW-011019009-101CH2S-P 2"-NPH-011019023-103CH2S-N 2"-RES-011028004-103CL4P-S 2"-RES-011028003-103CL4P-S 3"-BRN-011006302-103CS4P-H 2"-CRD-011013011-106CS1P-P 2"-HGO-011013021-103CS1P-S 14"-LGO-011023002-101CS1P-H 6"-NPH-011019007-101CH2S-P 24"-KER-011018001-101CS1P-H 24"-KER-011018001-101CS1P-H 40"-NPH-011018001-101CH2S-P 2"-RES-011040015-103CS1P-S 2"-RES-011040016-103CS1P-S 2"-HGO-011039022-103CL2P-S 1/2"-CHP-011054413-101CS1P-N 1/2"-CHP-011054411-101CS1P-N 6"-SLP-011099001-103CS1P-P 2"-HGO-011039004-103CL2P-P 2"-HGO-011005008-103CS2P-P
DS011-TRJR-480219 DS011-TRJR-480219 DS011-TRJR-480090 DS011-TRJR-480090 DS011-TRJR-480090 DS011-TRJR-480127 DS011-TRJR-480290 DS011-TRJR-480290 DS011-TRJR-480080 DS011-TRJR-480080 DS011-TRJR-480233 DS011-TRJR-480233 DS011-TRJR-480233 DS011-TRJR-480050 DS011-TRJR-480028 DS011-TRJR-480043 DS011-TRJR-480043 DS011-TRJR-480043 DS011-TRJR-480046 DS011-TRJR-480046 DS011-TRJR-480046 DS011-TRJR-480084 DS011-TRJR-480011 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480089 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480134 DS011-TRJR-480139 DS011-TRJR-480011 DS011-TRJR-480066 DS011-TRJR-480066 DS011-TRJR-480066 DS011-TRJR-480066 DS011-TRJR-480046 DS011-TRJR-480291 DS011-TRJR-480291 DS011-TRJR-480291 DS011-TRJR-480046 DS011-TRJR-480046 DS011-TRJR-480068 DS011-TRJR-480068 DS011-TRJR-480011 DS011-TRJR-480024 DS011-TRJR-480024 DS011-TRJR-480043 DS011-TRJR-480043 DS011-TRJR-480043 DS011-TRJR-480043 DS011-TRJR-480043 DS011-TRJR-480104 DS011-TRJR-480104 DS011-TRJR-480102 DS011-TRJR-480126 DS011-TRJR-480126 DS011-TRJR-480138 DS011-TRJR-480102 DS011-TRJR-480010
LP STEAM FUEL GAS SOUR OFF GAS SOUR WATER SOUR WATER CORROSION INHIBITOR FUEL GAS VENT GAS NEUTRALIZING AGENT NEUTRALIZING AGENT AMINE CLOSED DRAIN AMINE AMINE CLOSED DRAIN NAPHTHA HEAVY GAS OIL LAGO LAGO KERO NAPHTHA HEAVY NAPHTHA NAPHTHA VDU OFF GAS CRUDE RESIDUE RESIDUE VACUUM RESIDUE SOUR OFF GAS VACUUM RESIDUE VACUUM RESIDUE HAGO MP STEAM FRESH CRUDE RESIDUE ATM. RESIDUE ATM. RESIDUE RESIDUE NAPHTHA VENT GAS NITROGEN AIR SOUR WATER TOTAL NAPHTHA ATM. RESIDUE ATM. RESIDUE BRINE TOPPED CRUDE HVGO LAGO NAPHTHA KERO KERO HEAVY NAPHTHA VACUUM RESIDUE VACUUM RESIDUE HVGO NEUTRALIZING AGENT NEUTRALIZING AGENT SLOP OIL HEAVY GAS OIL HAGO
CDU/VDU UNIT (UNIT 011) BLIND LIST
CDU/VDU UNIT (UNIT 011) BLIND LIST
Line number
P&ID
Service
Line number
P&ID
Service
16"-RES-011039002-103CL4P-S 12"-RES-011039006-103CL4P-S 2"-SLP-011098013-103CS1P-S 2"-CRD-011003008-106CS1P-P 1/2"-CHP-011054413-101CS1P-N 1/2"-CHP-011054411-101CS1P-N 1/2"-CHP-011054413-101CS1P-N 1/2"-CHP-011054410-101CS1P-N 1/2"-CHP-011054413-101CS1P-N 1/2"-CHP-011054410-101CS1P-N 3/4"-KER-011022011-103CS1P-P 4"-VTG-011036003-101CH4S-S 2"-HGO-011009006-103CL2P-P 24"-NPH-011019006-101CH2S-P 3/4"-NPH-011019029-101CH2S-P 4"-RES-011027021-103CL4P-S 4"-RES-011027022-103CL4P-S 8"-PRW-011043003-101CS2P-P 6"-BFW-011043301-101CS1P-H 6"-WST-011098001-101CS2P-N 2"-SWA-011023301-101CS1P-N 2"-CRD-011002010-106CS1P-P 2"-CRD-011002009-106CS1P-P 4"-LGO-011030002-101CS1P-P 2"-BRN-011042007-103CS4P-P 2"-OIL-011033024-101CH2S-N 8"-MPS-011028302-103CS1P-H 3"-OIL-011033001-101CH2S-N 2"-BRN-011007011-106CS2P-H 18"-CRD-011006008-103CS1P-H 6"-BRN-011006001-103CS4P-P 2"-BRN-011007011-106CS2P-H 4"-CLD-011006309-103CS4P-P 3"-CLD-011006309-103CS4P-P 2"-SRW-011034003-101CH2S-N 8"-SRW-011033001-101CH2S-N 3"-CLD-011006309-103CS4P-P 1"-MPS-011230302-101CS1P-H 1"-MPS-011230301-101CS1P-H 1"-LPN-011230302-101CS1P-N 1"-INA-011230302-301CG2P-N 1-1/2"-AWR-011230302-101CS1P-N 1-1/2"-AWS-011230302-101CS1P-N 2"-CRD-011010008-103CS1P-P 2"-LGO-011010005-103CS1P-P 2"-LGO-011010006-103CS2P-P 2"-LGO-011043002-103CS1P-P 2"-OSW-011079301-101CS1P-N 24"-VAC-011030003-101CH4S-P 2"-BRN-011200004-106CS2P-N 2"-CRD-011008021-103CS1P-P 2"-SRW-011033024-106CH2S-N 2"-PIG-011075302-101CS1P-S 2"-LPF-011035302-101CH2F-N 2"-LPF-011035309-101CH2F-N 3/4"-AMN-011036021-103CH2S-P 36"-VAC-011030001-101CH4S-P 16"-VAC-011031001-101CH4S-H 36"-VAC-011030001-101CH4S-P 1"-PHO-011054430-101SD0P-N
DS011-TRJR-480103 DS011-TRJR-480103 DS011-TRJR-480136 DS011-TRJR-480006 DS011-TRJR-480126 DS011-TRJR-480126 DS011-TRJR-480126 DS011-TRJR-480126 DS011-TRJR-480126 DS011-TRJR-480126 DS011-TRJR-480052 DS011-TRJR-480094 DS011-TRJR-480017 DS011-TRJR-480046 DS011-TRJR-480046 DS011-TRJR-480066 DS011-TRJR-480066 DS011-TRJR-480112 DS011-TRJR-480112 DS011-TRJR-480112 DS011-TRJR-480054 DS011-TRJR-480004 DS011-TRJR-480004 DS011-TRJR-480080 DS011-TRJR-480107 DS011-TRJR-480086 DS011-TRJR-480139 DS011-TRJR-480086 DS011-TRJR-480011 DS011-TRJR-480011 DS011-TRJR-480011 DS011-TRJR-480011 DS011-TRJR-480011 DS011-TRJR-480011 DS011-TRJR-480086 DS011-TRJR-480086 DS011-TRJR-480011 DS011-TRJR-480290 DS011-TRJR-480290 DS011-TRJR-480290 DS011-TRJR-480290 DS011-TRJR-480290 DS011-TRJR-480290 DS011-TRJR-480018 DS011-TRJR-480018 DS011-TRJR-480018 DS011-TRJR-480110 DS011-TRJR-480233 DS011-TRJR-480080 DS011-TRJR-480274 DS011-TRJR-480015 DS011-TRJR-480088 DS011-TRJR-480214 DS011-TRJR-480091 DS011-TRJR-480091 DS011-TRJR-480275 DS011-TRJR-480083 DS011-TRJR-480083 DS011-TRJR-480083 DS011-TRJR-480128
VACUUM RESIDUE VACUUM RESIDUE SLOP OIL FRESH CRUDE NEUTRALIZING AGENT NEUTRALIZING AGENT NEUTRALIZING AGENT NEUTRALIZING AGENT NEUTRALIZING AGENT NEUTRALIZING AGENT KERO SWEET OFF-GAS HAGO NAPHTHA NAPHTHA ATM. RESIDUE ATM. RESIDUE WATER BOILER FEED WATER STRIPPED SOUR WATER SERVICE WATER FRESH CRUDE FRESH CRUDE LIGHT GAS OIL BRINE RECOVERED LVGO MP STEAM RECOVERED LVGO BRINE FRESH CRUDE BRINE BRINE HC CLOSED DRAIN HC CLOSED DRAIN SOUR WATER SOUR WATER HC CLOSED DRAIN MP STEAM LP STEAM NITROGEN INSTRUMENT AIR AUXILIARY CW AUXILIARY CW DESALTED CRUDE LAGO LAGO LAGO WATER VDU OFF GAS BRINE DESALTED CRUDE SOUR WATER PILOT GAS FUEL GAS FUEL GAS RICH AMINE VDU OFF GAS VDU OFF GAS VDU OFF GAS PHOSPHATE
2"-FLO-011076301-101CS1P-N 2"-SRW-011012009-101CH2S-P 2"-LPS-011200002-101CS1P-N 2"-AMN-011200003-103CS2D-N 2"-BFW-011200302-101CS1P-N 2"-NPH-011200004-103CH2S-N 4"-LPS-011024001-101CS1P-P 16"-CRD-011006003-103CS1P-H 1/2"-PHO-011054431-101SD0P-N 1/2"-PHO-011054431-101SD0P-N 1/2"-PHO-011054430-101SD0P-N 1/2"-PHO-011054430-101SD0P-N 2"-HGO-011038005-103CS1P-P 2"-SLP-011098018-103CS1P-S 3/4"-VTG-011200002-101CH4S-P 2"-PIG-011075302-101CS1P-S 2"-OIL-011200001-103CH2S-N 2"-SRW-011200005-101CH2S-N 2"-SRW-011200006-101CH2S-N 2"-SRW-011200007-101CH4S-N 2"-PIG-011075305-101CS1P-S 16"-CRD-011007012-103CS1P-H 2"-FLO-011040306-101CS1P-N 18"-CRD-011006002-106CS1P-H 2"-RES-011230001-101CS1P-N 2"-LGO-011230001-103CS1P-N 16"-VAC-011031001-101CH4S-H 2"-FLO-011076302-101CS1P-N 1/2"-INH-011054420-101SC1P-N 1/2"-INH-011054421-101SC1P-N 1/2"-INH-011054421-101SC1P-N 1/2"-INH-011054420-101SC1P-N 2"-CND-011200301-103CS1P-N 1/2"-INH-011054420-101SC1P-N 1/2"-INH-011054420-101SC1P-N 1/2"-INH-011054422-101SC1P-N 1/2"-INH-011054422-101SC1P-N 1"-CLD-011035302-101CH2S-N 2"-CND-011071309-101CS1P-H 2"-LPC-011071001-101CS1P-P 2"-LPC-011071007-101CS1P-P 4"-LPF-011079301-101CH2F-S 3"-AMD-011079301-101CH2S-P 2"-AMD-011079001-101CH2S-P
DS011-TRJR-480219 DS011-TRJR-480023 DS011-TRJR-480274 DS011-TRJR-480274 DS011-TRJR-480274 DS011-TRJR-480274 DS011-TRJR-480056 DS011-TRJR-480011 DS011-TRJR-480128 DS011-TRJR-480128 DS011-TRJR-480128 DS011-TRJR-480128 DS011-TRJR-480100 DS011-TRJR-480136 DS011-TRJR-480274 DS011-TRJR-480214 DS011-TRJR-480274 DS011-TRJR-480274 DS011-TRJR-480274 DS011-TRJR-480274 DS011-TRJR-480214 DS011-TRJR-480012 DS011-TRJR-480104 DS011-TRJR-480012 DS011-TRJR-480290 DS011-TRJR-480289 DS011-TRJR-480083 DS011-TRJR-480219 DS011-TRJR-480127 DS011-TRJR-480127 DS011-TRJR-480127 DS011-TRJR-480127 DS011-TRJR-480275 DS011-TRJR-480127 DS011-TRJR-480127 DS011-TRJR-480127 DS011-TRJR-480127 DS011-TRJR-480091 DS011-TRJR-480201 DS011-TRJR-480201 DS011-TRJR-480201 DS011-TRJR-480233 DS011-TRJR-480233 DS011-TRJR-480233
FLUSHING OIL SOUR WATER LP STEAM LEAN AMINE BOILER FEED WATER HEAVY NAPHTHA LP STEAM FRESH CRUDE PHOSPHATE PHOSPHATE PHOSPHATE PHOSPHATE HEAVY GAS OIL SLOP OIL SOUR OFF GAS PILOT GAS RECOVERED LVGO SOUR WATER SOUR WATER SOUR WATER PILOT GAS FRESH CRUDE FLUSHING OIL FRESH CRUDE VACUUM RESIDUE LVGO VDU OFF GAS FLUSHING OIL CORROSION INHIBITOR CORROSION INHIBITOR CORROSION INHIBITOR CORROSION INHIBITOR PUMPED HOT CONDENSATE CORROSION INHIBITOR CORROSION INHIBITOR CORROSION INHIBITOR CORROSION INHIBITOR HC CLOSED DRAIN PUMPED HOT CONDENSATE LP CONDENSATE LP CONDENSATE FUEL GAS AMINE CLOSED DRAIN AMINE CLOSED DRAIN
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 32.
CDU/VDU START UP Document Number
Description
SA-JER-DS011-TRJR-400002
CDU/VDU START UP
Rev. 01
Procedure No.
INTERMEDIATE PROCEDURE FOR
CDU/VDU START UP ...
Date: 10-NOV-2011 Rev. : 0 1
UNiT 011 -CRUDE DlSTlLLATlON UNITTRAIN 1
I
Paa. : 1of 48
DOCUMENT: SA-JER-DSO11-TRJR-400002
INTERMEDIATE PROCEDURE FOR
CDU/VDU START UP UNIT 011 - CRUDE DlSTlLLATlON UNITTRAIN 1
Note: This docurnent does not replace the corresponding "Operating Procedure" or "OPERGUID" which will be developed by SATORP. .........
. .
l ..............
................
REV.
DATE
/
DlSClPLlNECODE PRO
DESCHIPTION APPROVED FOR CONSTRUCTION ISSUE FOR REVIEW
1
DOCUMENTTYPE MAN
1
UNlT
1
SYSTEM
011
Docurnent Class: 2 O Action
Legend
1
o
O
Verification Safet;~ction
1 B - Board Operator j F- Field Operator
1 S - Shift Supervisor
1
INTERMEDIATE PROCEDURE FOR
CDUIVDU START UP UNlT 0 1 1 - CRUDE DISTILLATION UNlT TRAlN 1
I
Procedure No. 011-IP-O002 Date: 10-NOV-2011 Rev. : 0 1 Pag. : 2 of 48
LEVEL ll LOGlC DIAGRAM
pressurized
100
PRE START UP OPERATIONS
200
FILLING OF THE UNlT
300
COLD GASOIL RECIRCULATION
400
HOT GASOIL CIRCULATION
500
CDU START UP
INTERMEDIATE PROCEDURE FOR
CDU/VDU START UP UNIT011- CRUDE DlSTlLLATlON UNITTRAIN 1
I
600
VDU START UP IN LlNE WlTH CDU
700
VDUSTART UPAFTER CDUALREADY IN OPERATION
800
AMlNE SYSTEM START UP
Procedure No. Oll-IP-O002 Date: IO-NOV-2011 Rev. : 0 1 Pag. : 3 of 48
STABLE STATE S7 Amine section in service and
900
FINAL CHECK LlST
FINAL STATE CDU / VDU UNlT in normal operation
Note 1:Steps 600 and 700 are two different alternatives t o start VDU, which depends o f operationai reauirement. Hence, stable state 6 is applicable after both steps.
INTERMEDIATE PROCEDURE FOR
CDUIVDU START UP ...
UNIT 011 - CRUDE DISTILIATION UNlTTRAlN 1
I
Procedure No
.
011-IP-O002 Date: 10-NOV-2011
. .
Rev : 0 1 Pag : 4 of 48
LEVEL ll SUMMARY
1
...................................................................................................................................... 4 INlTlAL STATE SHEET ................................ ........................................................................................5
SUMMARY
100
PRE START UP OPERATIONS
STABLE STATE 1SHEET 200 210 220
.............................................................................................. 7
.....................................................................................................................8
.........................................................................................................9 .......................9 FILL-UP KERO ClRCUlTS WlTH SWEET NAPHTHA ............................................................ 10
FlLLlNG OF THE UNIT FILL-UP NAPHTHA DRUMS D-0004 AND D-0003 WlTH SWEET NAPHTHA
...................................................... 11 ........................................................................ 12
230
FILL-UP LAGO AND HAGO CIRCUITS WlTH GASOIL
240
FILL-UP LVGO AND HVGO WlTH GASOIL
250
FILL-UP PREHEATTRAIN. ATMOSPHERICAND VACUUM RESIDUE WlTH GASOIL
.............13
....................................................................................................................16 17 COLD GASOIL RECIRCULATION .......................................................................................... 300 19 STABLE STATE 3 SHEET ...................................................................................................................... 20 HOT GASOIL RECIRCULATION ............................................................................................ 400 22 STABLE STATE 4 SHEET ..................................................................................................................... 500 CDU START-UP ................................................................................................................. 23 510 KERO ClRCUlTS START-UP ........................................................................................... 23 520 LAGO ClRCUlTS START-UP ............................................................................................ 24 S30 HAGO ClRCUlTS START-UP ............................................................................................ 25 540 NAPHTHA CIRCUITSSTART-UP .................................... ................................................ 25 ........................................26 550 ATMOSPHERIC RESIDUE CIRCUITS START-UP ................... . . S60 DESALTER START-UP .................................................................................................... 26 S70 STEAM GENERATION START-UP ...................... . .......................................................... 27 29 STABLE STATE 5 SHEET ..................................................................................................................... STABLE STATE 2 SHEET
600 610 620
................................................................................... 30 ........................... ............................................ 30
VDU START- UP IN LlNE WlTH CDU TEMPERED WATER SYSTEM START-UP
...................................................................................... 30 630 VACUUM HEATER START-UP ..................................... ................................................ 31 640 LVGO ClRCUlTS START-UP ............................................................................................. 32 650 MVGOfHVGO ClRCUlTS START-UP .............................................................................. 32 VDU START- UP WITH CDU ALREADY IN OPERATION ........................................................36 700 720 LVGO ClRCUlTS START-UP ............................................................................................. 38 730 MVGO/HVGO ClRCUlTS START-UP .............................................................................. 39 STABLE STATE 6 SHEET .................................................................................................................... 41 AMlNE SYSTEM START UP ............................................................................................... 42 800 STABLE STATE 7 SHEET ..................................................................................................................... 44 900
VACUUM SYSTEMS START-UP
.............................................................................................................45 ........................................................................................................................... 46
FINAL CHECKLIST
FINAL STATE SHEET
Procedure No. Oll-IP-O002
INTERMEDIATE PROCEDURE FOR
CDUIVDU START UP I
UNlT 011 - CRUDE DlSTiLLATiON UNiTTRAlN 1
Date: 10-NOV-2011 Rev. : 01 Pag. : 5 of 48
LEVEL ll INITIAL STATE SHEET INiTlAL STATE CDUIVDU Unit purged and
1
pressurized
1
Unit purged and inerted according t o intermediate Procedure Oll-IP-0001. Unit oxygen content is iess than 0.5 vol%. Positive pressure is maintained in the entire Unit: Fuei gas pressure (0.3 barg): feed, prefiash atmospheric heater, atmospheric distillation, vacuum heater, vacuum distillation, and siop cooiing sections. - Nitrogen pressure (0.3 barg): desalting water, desaiter, offgas compressor, amine sections. Chemicai injections points, Demulsifier, Corrosion and Neutraiising, blockvalves and biinds are in ciosed position. Vent and drains valves are in close position. Rotary equipment have been inspected and tested. Ail supporting auxiliary facilities for running of equipments, e.g. seal oil, lube oil and cooling water pumps, must be started and tested before putting the main equipment en service. Strainers at pump suction iine are cieaned, instaiied, orientated correctly and pressure indicators are fitted. All instruments, anaiyzers and control systems are ready for service. Sampiing connections are ciosed. Safety reiief vaives have been tested and instalied. isoiation valves are in open position. Heat tracing shaii be established. Ail the utiiity, drains and process blinds are open. Spectacie biinds are in the start-up position. Aii Process Battery limits blind are i n the start-up position. Blind list should be marked-up t o date. Aii safety equipment is instaiied and commissioned, e.g. eye wash baths, showers. Aii fire fighting equipment are instaiied. Aii safeguarding systerns cornmissioned, e.g. relief valves, interlocking vaive systems, fire protection systems, remote operated vaive systerns etc. The connection t o the flare header is fuiiy operationai. Furnace refractories have been dry-out.
l
1 Note: Gasoii from BL shaii be avaiiabie to star-up the Unit. Note: Sweet Naphtha from NHDTshall be availabie t o proceed with the start-up of CDUIVDU. Sweet Naphtha composition would satisfy the specification required for the first start-up o f the NHDT. ASTM distillation similar t o the NHDT design feed ASTM distillation
UTlLiTlES o Aii utiiities avaiiable. o Fiare systems avaiiabie.
. ..-
INTERMEDIATE PROCEDURE FOR
CDUIVDU START UP >-
UNiT011- CRUDE DlSTlLLATlON UNlTTRAlN 1
I o o
o
Procedure No. Oll-IP-O002 Date: 10-NOV-2011 Rev. : 0 1 Pag. : 6 of 48
Power supply available. Oiiy water system in service. Closed drain and Arnine drain systerns in s e ~ i c e .
MATERIAL o Bottie and cylinders t o take sarnples are available. o Means o f cornrnunications available (walky-taikies), SAFETY
O O O
O O
O
Extinguishers are in position and available. Stearn hoses and monitor hoses are available. Fire water system, safety showers, gas sensors are available. Safety showers are available. Monitor hoses are available. Personal warning systerns are provided (like Hydrogen Sulphide detector).
Note: Operator shall check that there is no gap between the initial state described above and the current situation of the systern. If any gap is identified, operator shall take the necessary actions t o close this gap before continuing with the next step.
INTERMEDIATE PROCEDURE FOR
CDUIVDU START UP UNiT 011 -CRUDE DlSTlLLATlON UNlTTRAlN 1
I
Procedure No. Date: 10-NOV-201% Rev. : 0 1 Paa. : 7 of 48
LEVEL ll ACTIONS 100
PRE START U P OPERATIONS L7
1
(B) CIose al1 the control valves of the unit.
o (F) Close al1 the bypass valves of the control valves of the unit. (0) Close ail the on-off valves (XV's and N ' s ) of the unit.
INTERMEDIATE PROCEDURE FOR
CDUIVDU START UP UNlT 011 - CRUDE DiSTiLLATlON UNlTTRAlN 1
1
Procedure No. Date: 10-NOV-2011 Rev. : 0 1 Pag. : 8 of 48
LEVEL ll STABLE STATE 1SHEET
STABLE STATE S1 CDUIVDU Unit prepared for filling
o o
1
o o o
Unit oxygen content is less than 0.5 vol%. Positive pressure is maintained in the entire Unit: - Fuel gas pressure (0.3 barg): feed, preflash atmospheric heater, atmospheric distillation, vacuum heater, vacuum distillation, and slop cooiing sections. Nitrogen pressure (0.3 barg): desaiting water, desalter, offgas compressor, amine sections. All blinds have been removed and located ln the start-up position. All control valves in the unit and their bypasses are closed. Ali on-off vaives (XVs and ZVs) are closed.
UTlLlTlES o Al1 utilities available. o Flare systems availabie. o Power supply available. o Oily water system in service. o Ciosed drain and Amine drain systems in service. o Flushing oil availabie. Storage tanks will supply fiushing shall be prepared t o send gasoil to CDUIVDU. o Sweet naphtha stored ln the Naphtha tanks shali be prepared t o send to CDUIVDU in reverse flow inlet to CDUIVDU unit from NHDT unit. MATERIAL o Means of communications available (walky-talkies). SAFETY
O O
O
I
O
O O
Extlnguishers are in position and available. Steam hoses and monitor hoses are available. Fire water system, safety showers, gas sensors are available Safety showers are available. Monitor hoses are available. Personal warning systems are provided (like Hydrogen Sulphlde detector).
Note: Care shouid be taken during filling of vessels to avoid Overfilling and field operator to closely communicate with board operator during these activities. Field operator shall verify and check the level indicatlon and ensure direct observation of the level In the vessel when filling. Board operator shall be stopping the filling process before reaching the maximum level.
Procedure No.
INTERMEDIATE PROCEDURE FOR
Oll-IP-O002
CDUIVDU START UP ..
.
Date: 10-NOV-2011 Rev. : 0 1 Pag. : 9 of 48
UNlT 011 - CRUDE DiSTiLLATlON UNlT TRAlN 1
i
LEVEL ll
200
1
FlLLlNG OF THE UN17
210 FILL-UP NAPHTHA DRUMS D-0004 AND 0-0003 WlTH SWEET NAPHTHA
n
1
(B) Notify t o NHDT personnei that start aligning the sweet naphtha (iines 4"-HCB-111017009 and 8"-NPH-111018002) path t o the CDU unit.
o (F) Open bypass of the checkvalve, blockvalve at battery limit on Sweet Naphtha on line 8"NPH-011021002 and 4"-NPH-011098003. o (F) Align Naphtha reverse fiow inlet t o unit from NHDT unit. o (F) Verify that flow control valve FV-0062, iocated discharge line G-0007 is close. o (F) Open giobe valve and blockvalve near t o 0-0004 on line 4"-NPH-011021003 and route the start up Naphtha t o D-0004. o (F) Ensure that ZV-0008 (located on boot D-0004) and LDV-0026 are close t o avoid send hydrocarbon t o the 0-0006. o (F) Adjust the fiowrate of naphtha t o 0-0004 through the blockvalve filiing line. U (B/F) Verify iiquid leve¡ in 0-0004 (LT-0024) and operator check the ievel indicator LG-0023. Fill
D-0004 up t o 50%. O (B) Open ZV-0007 (iocated on bottom D-0004), and ensure the line discharge pump G-0005
(line 8"-NPH-011019003) is aligning t o the coiumn C-0002 through FV-0019, and t o E-0021 via t o D-0005 through FV-0025. o (F) Start the filling the CDU Naphtha circuit by gravity, and reestabiish Naphtha inventory t o NLL (50%) i n D-0004 when it is being required. o (F) Confirm fill up suction line CDU refiux pumps G-000SAIB. o (F) Close giobe and blockvalve in filling line t o D-0004,4"-NPH-011021003.
11 Note: Once the Naphtha drum D-0004 circuit has been filied, proceed t o fiil Naphtha drum D-0003 o (F) Align the Naphtha from BL t o 0-0003, using the line4"-NPH-011021006 (located
downstream t o FV-0062) and proceed t o open the 4" globe vaive. o (F) Open block vaives on start-up Naphtha filiing line to the G-0003 A j B suction iine (8"-NPH-
011012001), and routed t o the 0-0003.
U (BjF) Ensure that ZV-0022 (iocated on boot 0-0003) and LDV-0008 are close t o avoid send hydrocarbon t o the 0-0006. o (F) Adjust the flowrate of naphtha t o D-0003 through the blockvalve filling iine.
U (B/F) Verify iiquid levei i n D-0003 (LT-0004) and operator check the level indicator LG-0005. Fili D-0003 up t o 50%. o (F) Start the filling the Prefiash Naphtha circuit by gravity, and reestablish Naphtha inventory
t o NLL (50%) in D-0003 when it is being required. o (F) Confirm fiii up suction line Prefiash reflux pumps G-0003AjB.
U (B) Set the ievei control LC-0006 iocated i n the bottom of 0.0003, in auto mode. Adjust set point at 60%. o (F) Verify during the filling the liquid ievel in 0-0003 (LT-0006j0004).
1
INTERMEDIATE PROCEDURE FOR
CDUIVDU START UP UNIT 011 - CRUDE DISTILLATION UNlT TRAiN 1
i
I I
o
Procedure No. Oll-IP-0002 Date: 10-NOV-2011 Rev. : 0 1 Pag. : 10 of 48
(F) Close globe and block valve i n filling iine, when the ievel in D-0003 t o reach 60% of liquid level.
Note: At this step, the drums D-0003 and 0-0004 are filled and proceed t o fill KERO PA and KERO product circuits. 220 FiLL-UP KERO CiRCUlTS WlTH SWEET NAPHTHA
o o o o
[7
(F) Align the Naphtha from BL t o 0-0004, uslng the line 4"-NPH-011021003 and route t o the start up Naphtha line t o 0-0004. (F) Ensure the line discharge pump 6-0005 (line 8"-NPH-011019003) is aiigning t o the column C-0002 through FV-0019, and the FV-0025 going t o E-0021 via to 0-0005 1s closed. (F) Proceed t o open globe and block valve i n filling line t o D-0004,4'-NPH-011021003. (F) Start the CDU Refiux Drum Pumps, G-0005 A or 0, ensure fiow rate below at minimum fiow (65.1 T/h) setting FV-0019 at this value, when the level in the CDU Reflux Drum, 0-0004, reaches 90 %. (F) Ensure the line discharge pump G-0005 (line 3'-NPH-011019008) is aligning t o column C0002 over head line.
O (B) Set the control valve FV-0019 of reflux t o atmospheric column C-0002, in manual mode. Adjust set point at lo%, when the level in 0-0004 reaches 60%.
O (B) Verify liquid level i n chimney tray o f KERO during this operation (tray #44) (LT-0010/0012). O (B) Open ZV-O077 (Kero draw-off form C-0002). and ensure the suction line pump G-0008AIB and inlet t o the column C-0004 is aligning through LV-0034.
O (B) Set the level Kerosene stripper C-0004 control vaive LY-0034 ln auto mode. Adjust set point for LC-0034 at 60%.
O
(B) Confirm in LT-0034 (Level transmitter on C-0004), that fiooding through the towerfill up by
O
gravity Kerosene Stripper C-0004. (F) Field operator shall verify the leve1 indicator LG-0035 and ensure the liquid level at the C0004 bottom is around of 60%. (F) Confirm fill up suction line KERO product G-0009AlB. (F) Confirm fill up suction line KERO pump around G-0008A/B. (F) Close block valves on filling line t o the D-0004. (B/F) Start G-0008 A or 0, ensure that flow rate is above at minimum thermal fiow (256 T/h). (F) Check KERO pump around circuits have being filled (volume approx 200 m3). (F) Stop the pump 6-0008 A/B and drain water as required at the low point in the circuits. (F) Start G-0009 A or B, ensure that the fiow rate 1s above at minimum flow (56 T/h). (F) Check KERO product circuits have being filled up t o product BL (volume approx 100 m3). (F) Stop the pump 6-0009 A/B and drain water as required at the low point in the circuits. (BjF) Monitor regularly the liquid level in C-0004.
O
(F) Reestablish Naphtha inventory t o NLL (50%) i n 0-0004 when it is being required.
O
(F) Ciose globe and block valve in filling llne.
o
o o
o U
o o o
o o
Note: After D-0003,D-0004 and KERO circuits are fiiled; proceed t o fill discharge circuit from G-0005 t o E-0021lD-0005 t o make inventorv in this vessel.
o o
(F) Open FV-0025 via E-0021 and D-0005, and verify the liquid level in 0-0004 (LT-0024) and operator check the level indicator LG-0023. (F) Ensure that ZV-0010 (located on boot D-0005) and LDV-0032 are close t o avoid send hydrocarbon t o the 0-0006.
1
INTERMEDiATE PROCEDURE FOR
CDUIVDU START UP UNlT 011 - CRUDE DlSTiLLATlON UNlT TRAlN 1
i U
o
Procedure No. Date: 10-NOV-2011 Rev. : 0 1 Pae.: 11of 48
(B/F) Verify iiquid levei in D-0005 (LT-0030) and D-0004 (LT-0024). Field operator t o regularly check the liquid level. (F) When liquid level i n D-0005 is filling up t o lo%, proceed to stop 6-0005 pumps.
I
Note: For the first start-up 500 m3 approx of Sweet Naphtha from externa1source have t o be charged in this circuit.
1
230 FILL-UP LAGO AND HAGO ClRCUlTS WlTH GASOIL (F) Open 4" two block vaives on the fiushing oil connection iocate downstream on control vaive FV-0023 and align gasoil from washing oil header t o fill up on chimney tray #30 of C-0002 until HLL iiquid level. (B/F) Confirm in LT-0010 that tray iiquid ievei is increasing. (0) Open the control vaive LV-0038. (B/F) Confirm in LT-0038 (ievel in LAGO stripper C-0005) that fiooding through the tower fiii up by gravity LAGO Stripper C-0005. Field operator regularly checks the liquid level. (0) Set the levei control valve LC-0038, in auto mode. Adjust set point at 60%. (F) Align the LAGO PA circuit. (F) Notify t o NHDT unit, if this system is avaiiable t o fill-up with gasoil. (F) Fill up suction iine LAGO pump around G-0010AfB. (F) Fill up suction iine LAGO product G-0011A/B. (B/F) Start G-0010 A o r B, ensure that the flow rate is above at minimum thermal flow (162 Tlh). (F) Fiil LAGO pump around circuits (voiume approx. 185 m3). (B/F) Stop the pump G-0010 and drain water as required at the iow point in the circuits. (B/F) Start G-0011 A o r B. ensure that the flow rate is above at minimum flow (28 Tlh). (F) Check LAGO product circuits have being filled up t o product BL (volume approx 5 1 m3). (B/F) Stop the pump G-0011 and drain water as required at the low point in the circuits. (0) Open control vaive FV-0024 t o estabiish ievel in chimney # 15. (0) Check liquid leve! in chimney tray of HAGO during this operation. (F) Align the HAGO PA circuit. (F) Notify t o NHDT unit, if this system is available t o fill-up with gasoil. (F) Open 2" block vaives on flushing oil line, connected in the pump G-0012 A and B (HAGO Pump around pumps) suction line. (F) Open 2" block vaives fiushing oii in iniet iine to E-0017 sheli side, which could heip t o fill up this circuits. (F) Fiil up suction line HAGO pump around G-0012AfB. (0) Open the control vaive LV-0040. (B/F) Confirm in LT-0040 that fiooding through the tower fili up by gravity HAGO Stripper C0006. Field operator regularly checks the iiquid ievel. (0) Set the ievei control vaive LC-0040, in manual mode. Adjust set point at 60%. (F) Fiil up suction line HAGO product G-0013AfB. (B/F) Start 6-0012 A or B, ensure that the flow rate is above at minirnum thermai flow (266 Tlh). (F) Fiii HAGO pump around circuits (voiume approx 175 m3). (B/F) Stop the pump G-0012 and drain water as required at the low point in the circuits. (B/F) Start G-0013 A or B, ensure that the fiow rate is above at minimum flow (22 T/h). (F) Check HAGO product circuits have being filled up t o product BL (volume approx 51 m3).
INTERMEDIATE PROCEDURE FOR
CDU/VDU START UP UNiT 011 - CRUDE DiSTiLlATlON UNiT TRAlN 1
I
I 1 1
I
Procedure No. 011-IP-O002 Date: 10-NOV-2011 Rev. : 0 1 Pag.: 12 of 48
0
(BJF) Stop the pump G-0013 and drain water as required at the low point in the circuits.
n
(F) Close block vaive on filling iine when the levei in trays and stripper t o reach normal iiquid level (50%).
Note: For the first start-up 462 m3 approx of gasoil from externa1source have to be charged in this circuit. 240 FILL-UP LVGO AND HVGO WlTH GASOIL
o
O o
U
(F) Verify that fiow control valve FV-0046 and FV-0038. (BJF) Verify that fiow control valve FV-0144, located downstream of E-0029, shell side, is ciosed. (F) Open 4" t w o block vaives on the fiushing oil connection, directiy connected t o the LVGO PA line, located downstream of control valve FV-0038 near t o top vacuum coiumn C-0003 and align gasoil from flushing oii header t o fiil up on chimney tray # l o of C-0003 untii HLL iiquid ievei on LC-0044. (8) Open ZV-0083 (LVGO draw-off from C-0003).
n
(F) Confirm fill up suction line LVGO pump G-0015 AlB. (8) Set the flow control valve FV-0046, in manual mode. Adjust set point at 10% t o estabiish
n
(B) Set the flow control valve FV-0038, in manual mode. Adjust set point at 156 Tlh t o estabiish
O
(B/F) Start G-0015 A or B, ensure that the fiow rate is above at minimum thermai fiow (156
o
ievel in chimney tray # 9 (MVGO draw-off tray). recirculation t o Column.
o
T/h). (B/F) Stop the pump G-0015. (F) Drain low point of circuits out t o remove water. (B) Check liquid level in chimney tray of MVGO during this operation (tray #9) through LC-0049.
O O ( 0 )Open ZV-0086 (MVGO draw-off from C-0003).
o
(F) Fill up suction line MVGO pump G-0016A/B. (SJF) Open 2" two blockvalves and blind on the flushing oil connections located on inlet iine MVGO pumps G-0016 A and B and aiign gasoil from flushing oil i n case it is required. (SJF) Open 4" two block valves and blind on the fiushing oil connections located downstream HVGO pump around filter S-0001 and align gasoil from fiushing oil. (8) Check level in chimney tray of HVGO during this operation (tray #8) on LC-0048.
O
(8) Open ZV-0081 (HVGO draw-off from C-0003).
o
(F) Open 2" t w o block vaives on the fiushing oil connections located on inlet line HVGO pumps 6-0017 A and 8 and align gasoil from flushing oii in case it is required. (B) Open the following 2" fiushing oll injection on HVGO circuits i n case it is required: Downstream line E-0019AlD: 2". - Downstream line E-0016AIB: 2". Downstream line E-0010A: 2".
o o o
o
-
Downstream line E-0030A: 2".
(8) Keeping ciose the control valve FV-0051. U
(8) Keeping close the control valve PV-0338 and manual valves on Battery limit line of Hot HVGO to DHCIMHC unit on line 12"-HGO-011038004,
I
O
(8) Open manuaiiy control valve FV-0051 into the column. (BJF) Start G-0017 A or 8, ensure that the fiow rate is above at minimum fiow (494TJh).
INTERMEDIATE PROCEDURE FOR
CDUIVDU START UP UNiT 011 -CRUDE DlSTlLLATlON UNiTTRAlN 1
i o
O
o
1
o
O O o U
O o
o o
o o
O o
o
o o
o
D o
O
U o o
o
Procedure No. Oll-IP-O002 Date: 10-NOV-2011 Rev. : 0 1 Paa. : 14 of 48
(F) Check that Desalted Crude Pumps G-0002 A/B suction lines are full. (8) As soon as desalted crude pump suction line is full, start the pump to fill-up the exchanger train up to the prefiash column, Oll-C-0001. (F) Open al1 the manual valves at heat exchanger iniets and outlets and their bypass on the gasoil side, from G-0001to Preflash Coiumn C-0001. (F) Check that al1 heat exchanger train downstream G-0002 A/B until C-0002, are compietely fui1 on sheli and tube sides by opening the vents untii gasoil fiow is obtained. (0) Open control valve FV-0006 at inlet C-0001. (BjF) Check liquid levei in C-0001with bottom transmitter LT-0003 A/B and operator check the level indicators LG-0002A/B. (F) Field operator shall verify the level indicator LG-0002A/B and ensure the liquid ievei at the C-0001bottom is around of 60%. (S/F) Open 2" two block valves and blind on the flushing o11 connections located on inlet line Preflash bottom pumps G-0004 A and B and align gasoil from flushing oil in case it is required that couid help to fill the preheat train, F-0001 passes and C-0002 bottom coiumn. (B) Open ZV-0002 (C-0001 Bottom). (F) As soon as the high level of the Oll-C-0001 1s reached, the crude will begln to flow by gravity, flood the prefiash bottom pumps 6-0004 A/B, and fill-up the rest of hot crude preheat exchanger train and the crude Heater, Oll-F-0001. All the low points wiil be drained out t o remove water. (F) Fill up suction iine Prefiash bottom pump G-0004AlB. (F) When fiiling by gravity is not effective, the Prefiash Bottom Pump, Oll-G-0004 A/B, may be jogged to move the gas oii t o send to the bottom of the Atmospheric Column, Oll-C-0002. (0) Open FV-0008 (Mini-flow of G-0004 A/B pumps) and setting the flow rate through FC-0008 at 474 T/h. (F) Open drain low point of preflash column and circuits out to remove water. (F) Check that ail heat exchanger downstream G-0004 A/B, are compietely fui1 by opening the vents untii gasoil flow is obtained. (B) Open control vaives FV-0015 A-H at inlet passes to F-0001. (F) Check that the gasoil pass thought the Crude Heater F-0001. (F) Drain low point at heater F-0001outiet iine, in each of eight pass coils. (B/F) Check iiquid ievei in C-0002 with bottom transmitters LT-0124, LT-0020 and operator check the level indicators LG-0019. (F) Fieid operator shall verify the level indicator LG-0019 and ensure the liquid level at the C0002 bottom is around of 70%. (F) Open drain in low point bottom line in Atmospheric Column C-0002 to remove water. (S/F) Open 2" two blockvalves and blind on the flushing 011 connections located on inlet line Atmospheric Residue pumps G-0014 A and B and align gasoil from flushing oil i n case it is requlred that couid help to fill-up the F-0002 passes and C-0003 bottom. (0) Open ZV-0006 (C-0002 Bottom). (F) Confirm fill up suction line Atmospheric Residue pump G-0014AlB. (B/F) As soon as water is drained from the Crude Column C-0002 and the high liquid level is reached, the atmospheric Residue pumps G-0014 A or 8, can be started to pass through the F0002, and fill-up the bottom of the Vacuum Column C-0003. (0) Open FV-0032 (Mini-flow of G-0014A/B pumps) and setting the fiow rate through FC-0032 at 240T/h. (0) Open control vaives FV-0034 A-H at inlet passes to F-0002. (F) Check that the gasoil pass thought the Vacuum Heater F-0002. (F) Open drain low point at heater F-0002 outlet line, in each of eight pass coils.
Procedure No.
INTERMEDIATE PROCEDURE FOR
CDUIVDU START UP UNiT011 -CRUDE DISTILLATION UNlTTRAiN 1
I O
o o O o O
Date: 10-NOV-2011 Rev. : 0 1 Pae. : 15 o f 4 8
(BjF) Check iiquid ievel in Vacuurn coiumn C-0003 with bottom transmitter LT-0127, LT-O050 and operator check the ievel indicators LG-0049A/B. (F) Field operator shali verify the levei indicator LG-0049A/B and ensure the liquid ievel at the C-0003 bottom is around of 60%. (F) Open drain in low point bottom line in Vacuum Coiumn C-0003 t o remove water. (B) Open ZV-0016 (C-0003 Bottom). (F) Confirm fili up suction iine Vacuum Residue pump G-0018A/B. (B/F) As soon as water is drained from the Vacuum Coiumn and the high level is reached, the Vacuum residue pump, 011-G-0018, can be started t o fill-up the heat exchanger 011-E-0020 A-C/D-F ,011-E-0018 A-B/C-D. 011-E-0014 A-C/D-F and 011-E-0031 A/B.
O
(0) Open FV-0063 (Quench line) and setting the flow rate through FC-0063 at 190 T/h.
o
(F) Open 2" and 4" t w o blockvalves and blind on the flushing oil connections coming from FLO header directly connected t o G-0018AIB suction iine that could help t o fiil-up the preheat train and vacuum residue circuit. (F) Open 4" t w o block valves and biind on the fiushing oil connections coming from FLO header directly connected t o Vacuum Residue Quench line downstream FV-O063 that could help t o fill-up the C-0003 bottom and Quench line circuit. (B/F) Cornrnission the coid vacuum residue product fiow controller (FC-0053) and proceed to
o
17
open 16" block valve on line (16n-RES-011099003)Vacuum Residue t o E-0037 A/D. (F) Open drains in low point o f the vacuum residue t o storage t o remove water. (0) Open FV-0052 t o BL t o fill-up this circuit. (F) Open drains in i o w point of the vacuum residue rundown product t o DCU t o remove water. (F) Open manual block vaive on line (4"-RES-011039009) on discharge pump G-0018 A/B iine t o E-0037. (F) Open manually control valve LV-0050 on line 4"-RES-011039009, when line has been filledup, proceed t o close. (F) Open drain in iow point o f the slop & CDUIVDU long recirculation line t o removed water. (F) Closed manual vaive on fiiling line, when the levei reaches 60%. (F) Closed block and globe manual vaives on flushing oil line 6O located downstream FI-0112. Note: For the first start-up 2140 m3 approx of gasoil from externa1 source have to be charged in this circuit.
I
STABLE STATE S2 CDU/VDU Unit fili-up
1
LEVEL ll
I
Procedure No. Oll-IP-O002
INTERMEDIATE PROCEDURE FOR
CDU/VDU START UP UNiT 011 -CRUDE DlSTlLLASiON UNITTRAIN 1
i
Date: 10-NOV-2011 Rev. : 0 1 Pag. : 16 of 48
STABLE STATE 2 SHEET
l
STABLE STATE S2 cDu/vDU Unit fill-up
1
o o
CDUIVDU Unit fill-up with gasoil. Start-up interna1 recirculation line is lined up frorn vacuurn residue storage line to feed crude line, downstrearn of G-0001 discharge line, using the line 12'-SLP-011098019 (From Oll-E-0037 A/B/C/D inlet line, 16"-SPL-011099001-103CSlP-S to feed crude line downstrearn G-0001 A/B, 16"- CRD-011001005-106CSlP-H).
o o o
LP steam available. Cooling water system available. instrurnent airsystem available.
SAFETY O
O O
O
Extinguishers are in position and available. Stearn hoses are available. Monitor hoses are available. Safety showers are available.
INTERMEDIATE PROCEDURE FOR
CDU/VDU START UP UNlT 011 - CRUDE DiSTlLLATiON UNiT TRAIN 1
I
Procedure No. 011-IP-O002 Date: 10-NOV-2011 Rev. : 0 1 Pag. : 17 of 48
LEVEL II ACTIONS 300
1
COLD GASOlL REClRCULATlON
Note: Coid gasoil circulation is used for a few hours, using the start-up circulation lines t o drain water from equipments on the crude, atmospheric, and vacuum residue sides; it is aiso used t o commission instrument and eaui~ments. Note: Cold gasoil circuiation is composed for the foliowing equipments and main valves: 12" Start-up internal recirculation line lined up from E-0037 iniet line t o feed crude line (located downstream of GO001 discharge line), PV-0007, E-0001t o E-0009 AjB, D-0001&0002,G-0002 A/B, E-0010 t o E-0014, FV-0006, C-0001 (bottom), 6-0004, E-0016 to E-0020, F-0001, C-0002 (bottom), G-0014 A/B, F-0002, C0003 (bottom), E-0020, E-0018, E-0014, FV-0053, Vac. Residue line t o Slop&CDU/VDU header t o 12" Start-up internal recirculation line. (B/F) Start G-0002 A or 8, ensure that the flow rate is above at minimum flow. Open FV-0061 and setting the flow rate through FC-0061a t 665 T/h. Close the flow control valve FV-0006. (B/F) Start G-0004 A or B, ensure that the flow rate is above at minimum flow when the ievel in C-0001 to reach HH iiquid level of gasoil. Open FV-0008 and setting the flow rate through FC-0008 at 474 T/h. (B/F) Start G-0014 A or 8, ensure that the flow rate is above at minimum flow. Open FV-0032 and setting the flow rate through FC-0032 a t 240T/h. (B/F) Start G-0018 A or B, ensure that the flow rate 1s above at minimum thermai flow, when the ievei in C-0003 t o reach HH iiquid leve! of gasoil. Open FV-0063 and its bypass in case it is necessary t o maintain 132 T/h. Close theflow control valve FV-0053. (0) Put in cascade control LC-0003 (C-0001 bottom) and LC-0020 (C-0002 bottom) with the FV0015 A-H and FV-0034 A-H, respectively. (0) Set the pressure controller valve PC-0007 in manual mode and open. (0) Open at the same time, keeping the same flow through the flow controller valves FV-0053 and FV-0006 and increase the flow of the recirculation up t o 50% (600 T/h). I n case it is necessary open the HV-0008 (E-0014 A-C/D-F bypass), TV-0175 (E-0031 B by-pass). (0) When the system is stabiiized, put PV-0007 in regulation and at the same time proceed open FV-0053 until 100%. At this step, liquid level of C-0003 will be float and the recirculation flow rate is controlled by FV-0006 at 50%. (B/F) Check regularly used flow instrument FT-0001, that Unit is in internal circuiation of gasoil from G-0018 discharge to GOOOl discharge. FT-0006 can be used too. (BjF) Stop cold gasoil circuiation pump t o pump in the foliowing order: -
G-0004 (prefiash pump) G-0002 (desalter pump) (F) After the cold gasoil is stopped and allow water t o settle prior t o draining water from low point. Drain water from low point circuits, and column C-0001, C-0002 and C-0003.
-
-
I
o
G-0018 (vacuum residue pump) G-0014 (atmospheric residue pump)
Procedure No. 011-IP-O002
INTERMEDIATE PROCEDURE FOR
CDUIVDU START UP IRS+IReFeO
UNlT 011 -CRUDE DiSTiLLATlON UNiTTRAlN 1
1
o
o
o o
O
I
Date: 10-NOV-2011 R ~ V:.0 1 Pac. : 18 o f 48
(F) Check inlet pump filter. (B/F) Start the spare pump in the foilowing order and restari cold gasoil circulation: - G-0002 (desalter pump) G-0004 (preflash pump) - G-0014 (atmospheric residue pump) - G-0018 (vacuum residue pump) (F) I n case lt necessary replenish with gasoil t o start-up interna1 recirculation t o maintain the level in bottoms of columns. (F) Check inlet line filter periodically. - G-0002 A/B (pressure drop in PDT-0122/0127 on suction line) G-0004 A/B (pressure in PT-0148/0175 on suction line) - G-0014A/B (pressure drop in PDT-0035/0065 on suction line) G-0018A/B (pressure drop in PDT-0108/0109 on suction line) (B/F) stop gasoil circulation from time t o time and repeat the water drain from low point.
1 Note: A good safe ruie ir not restart a motor more than once in 30 minutes and not exceeding six times Note: When operating personnel are satisfied that water has been drained from the unit, gasoil heating can be started.
l
STABLE STATE S3 Circulating with Cold Gasoil
l
INTERMEDIATE PROCEDURE FOR
CDUIVDU START UP ..
I
,-
UNlT 011 - CRUDE DiSTiLLATlON UNlT TRAlN 1
Procedure No. Oll-iP-O002 Date: 10-NOV-2011 Rev. : 01 Pag. : 19 of 48
LEVEL ll STABLE STATE 3 SHEET
1
I I l
o o o o o o
Coid gasoil is circulating thought the start-up internal recirculation on cold circulation circuits. A-0001 (CDU Overhead Condenser) and A-0002 (Naphtha Condenser) ready for start-up. F-0001 (Crude heater) and F-0002 (Vacuum heater) ready for start-up. Fuel gas and Pilot gas control valves t o F-0001 and F-0002 are commissioned. G-0002, G-0004, G-0014 and G-0018 operated above at minimum flowrate. Chemicai package X-0003/0004/0005/0006 ready for start-iip.
UTILITIES o o
Cooling water available. Fuel gas and Pilot gas systems available.
MATERIAL o o
Chemicals start-up volume available in each package. Fuel gas and Pilot gas systems available.
SAFETY
O O
O O
Extinguishers are in position and available. Steam hoses are available. Monitor hoses are available. Safety showers are available.
INTERMEDIATE PROCEDURE FOR
CDUIVDU START UP UNlT 011 - CRUDE DlSTlLLATlON UNlTTRAlN 1
i
Procedure No. Oll-IP-o002 Date: 10-NOV-2011 Rev. : 0 1 Pag. : 20 of 48
LEVEL ll ACTIONS
l
400
HOT GASOIL RECIRCULATION
I
Note: Heater refractory dry-out phase are considered compieted for Atmospheric (F-0001) and Vacuum (F-0002) heaters, during pre- commissioning activities. U
(B/F) Verify that pumps associated t o interna1 circuiation G-0002, G-0004, G-0014, G-0018 are operating above minimum stabie flow. Maintain the flow of the recirculation at 600 T/h.
U
(B) Ensure that there isflow through al1 coiis of heater F-0001.
U
(8) Check the flow rate through F-0001 and F-0002 passes.
U
(8) Align pilot and fuei gas t o F-0001 burners in accordance with the start-up procedure for Charge Heater.
fl
(B/F) Commission the LP steam t o the superheating coiis and light heater burners according the charge heater F-0001 start-up. Recommended minimum flowrate t o the heaters t o 50 % design fiow (550 T/h).
Note: For more details refer t o Oll-IP-0007 for heater F-0001Shutdown/Start-Up (Step 200)
1
E
(BIF) During the first stage of start-up, the LP superheated steam wili be vented through their silencer t o atmosphere at safe location (Y-0003). LP steam t o the system and drain condensates at iow-points in the stripping steam piping.
O
(8) Open fue1 gas injection valves t o F-0001 and to begin to warm slowly circuiating gasoil with crude heater up to a ternperature o f about 120-150 QC, in this phase is needed t o evaporate water from hot circuits. (F) Veriíy that the pumps around (G-0008; G-0010 are G-0012) are stopped. (8) Start the air cooier A-0001 (CDU Overhead Condenser). (0) Start the air cooier A-0002 (Naphtha Condenser). (F) Check flange tightness on hot gasoil circulation circuits.
o
E
ü o
Note: Heat up the heater siowly with warming ramp by resetting the outlet temperature controiier TC0097 no more than 50 oC/h. See intermediate procedure Oll-IP-0007 for FURNACE F-0001 SHUTDOWNj START-UP (Steps 200).
a (8) Maintain this temperature approximately for few hours, using the start-up circulation lines t o remove traces of water from the unit. Stop circuiation, drain water, and restart up t o ail water has been removed. U (0) Check the temperature in the top o f the columns C-0001, C-0002 and C-0003. U (0) Commission the ievei control valve LDV-0026 in the boot o f the CDU reflux drum D-0004,
and adjust ievei set point at 50%.
O (0) Commission the levei control vaive LDV-0008 in the boot of the CDU prefiash reflux drum D0003, and adjust ievel set point at 50%.
l
INTERMEDIATE PROCEOURE FOR
CDUIVDU START UP UNlT011- CRUOE DiSTiLLATiON UNITTRAIN 1
I
Procedure No. Oll-iP-O002 Date: 10-NOV-2011 Rev. : 0 1 Pag.: 2 1 of 48
o (F) Fill until NLL Sour water Recovery Drum D-0006 with water, used utility connection lines 2"-SRW-011044014. U (8) Verify the transmitter level LT-00801 LT-0107 on Sour Water Recovery Drum 0-0006, when
levei reaches HLL commissioner levei control valve LC-0080 and send water t o the sour water stripper. O (B/F) Start G-0006 A or 8, ensure that flow rate is above of minimum flow (7.8 Tlh).
(8) Commission the level control vaive LC-0024 and FC-0025 (level control D-000% i n case water liquid level i n 0-0004 appear.
o
I
I
(0) Verify the transmitter level LT-0024 on CDU reflux drum 0-0004, when level reaches HLL:
-
Start CDU reflux pump G-0005.
O (0) Verify the transmitter level LT-00041LT-0006 on CDU preflash reflux drum 0-0003, when
o
levei reaches HLL: Start prefiash reflux pump G-0003, i n case it required.
(BjF) Monitor that liquid levels on the bottorns C-0001, C-0002 and C-0003 are stabilized and the hot gasoil recirculation is being stable. Additional gasoil can be brought from fiushing oii header as required.
O (B) Check the temperature at the bottoms C-0001, C-0002 and C-0003. Bottom colurnns wili
have very similar ternperature profiles.
Note: Hot gasoil is circulating though the start-up internar recircuiation line at 150 C : max.
INTERMEDIATE PROCEDURE FOR
CDUIVDU START UP UNlT 011 - CRUDE DlSTlLLATiON UNITTRAIN 1
1
LEVEL II STABLE STATE 4 SHEET
l
o
o o o
Cooling water available. Boiled feed water available. Steam system avaiiable.
o
o
I
l
CDUIVDU is in hot interna1recirculation with gasoil. Coil outiet temperature on F-0001heater at 150 gC max. A-0006 (Brine cooler) ready for start-up. Desalters D-0001 and D-0002 are filled-up and ready for start-up. All boots for D-0003,D-0004 and D-0005 are aligning t o Sour water Recovery Drum 0-0006.
o
1
STABLE STATE S4 Circulating with Hot gasoil
o
MATERIAL o Crude oil 1s available. o Chemicais are avaiiable. SAFETY O O O O
Extinguishers are in positlon and available. Steam hoses are available. Monitor hoses are available. Safety showers are avaiiable.
Note: At this stage two optlons are possible:
1. VDU is started in line with the CDU
2.
In this case, the atmospheric residue flows through the vacuum heater and 1s sent back to the separated crude tank using the vacuum residue pumps G-0018 (via the heat exchanger E-0020, E0018, E-0014 and off spec header). In this case, Steps 500 and 600 are performed simultaneously. VDU start-up is postponed If VDU 1s not started in iine with CDU, the VDU by pass line shall be opened. VDU ir isolated. The bottom of the column can be maintained with gasoil. The atmospheric residue is sent back to the separate crude oil tank using the atmospheric residue pump G-0014 (via the heat exchanger E-0020, E-0018, E-0014 and off spec header). In this case, after complete step 500, please refer to step 700.
Procedure No. Oll-IP-0002
INTERMEDIATE PROCEDURE FOR
..
CDUIVDU START UP
Date: 10-NOV-2011 Rev. : 01 Paa. : 23 of 48
TIIIWR.~~~
,
UNlT 011 -CRUDE DlSTiLiATlON UNlTTRAlN 1
1
LEVEL l l
500
CDU START-UP
Note: The immediate foilowing steps conslder the CDU Start-Up and VDU Start-Up is postponed. If the start-up of VDU is performed in line with CDU please refer to step 600.
I
o o
1
(F) Align crude o11 from crude tank though the normal feed iine 18"-CRD-011098001. (F) Align the bottom C-0002 column to the Slop & CDUIVOU long recirculation line using the foilowing: (F) Open blockvalve on line 12" bypass line, 12" RES-011027005-103CL4P-S, in order to
1
-
line up the discharge line of the Atmospherlc Residue Pump (Oll-G0014AIB) with the discharge line of the Vacuum Residue Pump (Oll-GOOl8AjB). (B) Close control vaive FV-0052 on line (10"-RES-011010003) from vacuum resldue to Coker
I
-
Unit. (F) Close blockvalve on line (16"-RES-011040006) of vacuum residue to storage Unit 661.
1
-
-
(F) Open manual blockvalve on line (16"-RES-011099003) on BL and aiign flow from discharge of G-0018to E-0037. (F) Open manual block valves (16"-SLP-011098001) on line Siop & CDU/recirculation Unit 681 and align flow downstream E-0037 to Siop & CDUIVDU long recirculation.
o (F) lsolate the circuits from VDU column and from EL (slop). (BjF) Start G-0001 A or B with discharge valve a bit open and open lt slowly to avoid hlgh
O
pressure in desalters. Ensure that flow rate is above of minimum flow (528 Tjh).
0 (8) Set the lnlet crude flow rate at 50% of the normal flowrate by adjusted ln the flow set point of flow controller FC-0001controlling PV-0007 (HS-0009A is activated to control crude lnlet flow rate to the unit through PV-0007). U (e) lncrease step by step the PC-0007, and proceed to reduce at the same time the Interna1
reclrculatlon line. O (B) Commission the crude pressure controller PC-0007 at the desaited inlet, setting at 13 barg
controlllng FV-0006 (HS-0009B is activated t o control desalter pressure through FV-0006).
O (8) Put i n cascade the liquld leve1 in C-0002 bottoms with FV-0053. If VDU is started in line with CDU, the FV-0053 shall be i n cascade with liquid levei i n C-0003. O (B) Add burners and increase slowiy the crude heater F-0001outiet temperature to 300 gC at a
rate of 30-50 gC/Hr by resetting the by resetting the outlet temperature controller TC-0097. O (8) Verify that the steam temperature downstream DS-0001(TT-0043) is above t o 250 ?C.
a
(B) Verify the profile of temperature in the columns C-0001 and C-0002, when the overhead refluxstabilizes the naphtha refiux then step by step put in service the KERO, LAGO, and HAGO pump around.
1
510 KERO ClRCUlTS START-UP U (BjF) Start KERO pump around G-0008 A or 8, ensures that flow rate is above at mlnimum
thermal flow (256 Tjh).
iNTERMEDlATE PROCEDURE FOR
CDUIVDU START UP i
1
UNiT 011 - CRUDE DlSTiLLATlON UNlT TRAIN 1
Procedure No. Oll-iP-O002 Date: 10-NOV-2011 Rev. : 0 1 Pag. : 24 of 48
ll (B) Set the ievel control LC-0010/ FC-0018 in cascade mode when the ievel reaches 40%.
U (8) Set the KERO internal reflux FC-0018, in auto mode; flow set point 133 T/h. U (8) Commission flow control valve FC-0003 on KERO pump around circuit. Adjust the set point
I
of flow controller t o 60% of its normal fiow rate (346 Tlh).
O (8) increase the pump around flow rate when the KERO draw-off tray temperature (TT-0103) approaches the expecting operating value (171 Y ) .
O (B) Set the temperature KERO pump around TC-0024, in auto mode. Adjust set point at 122 *C.
I
O (B) Commission the leve! controller (LC-0034) when the KERO draw-off tray #44 rises, start the fiow of liquid t o side stripper Oll-C-0004, setting the levei controller at 50%. o (F) Close manual blockvalves BL on line (8"-KER-011025012), Kerosene t o Storage Unit 661. o (F) Close manual blockvalves BLon line (8"-KER-011025001), Kerosene t o LP HDS Unit 101. o (F) Open manuai blockvalves on line (8"-KER-011098001) t o align Kerosene product from KERO side-stripper C-0004 back t o crude tank via Slop & CDUJVDU recircuiation line.
I 1 520 LAGO CIRCUITS START-UP (F) Verify that block valves BL on iine o f to (16'-LGO-011010001) / from (16"-LGO-011098002) Naphtha Splitter Reboiler in NHDT Unit 111are close. (B) Commission the pressure differential control valve PDV-0385. (F) Start LAGO pump around G-0010 A or B, ensure that flow rate is above at minimum thermal flow (162 T/h). (B) Set the on the LAGO internal reflux FC-0024, in auto mode; flow set point 195 T/h. (B) Commission the flow control vaives FC-0023 on LAGO pump around circuit. Adjust the set point of fiow controiler t o 60% of their normal fiow rate (421 Tlh). (B) lncrease the pump around fiow rate when the LAGO draw-off tray temperature (TT-0106) approaches the expecting operating value (247gC). (B) Set the temperature LAGO pump around TC-0112, in auto mode. Adjust set point at 201 QC. (B) Commission the ievei controller (LC-0038) when the LAGO draw-off tray #30 rises, start the flow of iiquid t o side stripper Oll-C-0005, setting the level controller at 50%. (F) Close manual blockvalves BL on line (6"-LGO-011025003) LAGO t o LP HDS Unit 101, and on iine (6"-LGO-011098002) LAGO t o HP HDS Unit 091. (F) Close manual block valves BL on line (6"-LGO-011025002) LAGO t o Storage Unit 661. (F) Open manual block vaives on line (6"-LGO-011098009) t o align LAGO product from LAGO side-stripper C-0005 back t o crude tank via Slop & COU/VDU recirculation line. (F) Start LAGO product pump G-0011 A or B, ensure that flow is above at minimum flow (28 TIh). (B/F) Commission the flow control vaives FC-0027 Stripping steam t o C-0005 when the steam temperature downstream FV-0021(TT-0363) is above t o 250 '
UNlT011- CRUDE DISTILLATION UNlTTRAlN 1
,
Procedure No. Oll-IP-0011 Date: 10-OCT-2011 Rev. : 0 1 Pag. : 13 of 15
LEVEL III FINAL STATE SHEET FINAL STATE Amine Section in Normal operation
o
Rich amine pump G-0023.4 or B in operation. Lean amine flow aligns to column C-0007. Sour off-gas aiigns to column C-0007. Column overhead C-0007 align to heater Flare Systern/F-0002.
o
All utilitv services (plant air, instrument air, cooling water, service water, nitrogen, fue1 gas, LP
o o o
steam) are available at the unit Battery Limit.
SAFEN
O O O O
O
Amine Regeneration Unit shali be prepared to stop the sending of lean amine to amine absorber column. Amine drain drum Oll-D-0025 shall be available. Extinguishers are in position and availahie Monitor hoses are available Safety showers are available
E
IIClllrllPiU,~lnY
TRla~trmrw
iNTERMEDiATE PROCEDURE FOR
AMINE SECTiON UNlT 011 - CRUDE DISTILLATION UNlTTRAlN 1
Procedure No. 011-IP-O011 Date: 10-OCT-2011 Rev. : 0 1 Pag. : 14 of 15
LEVEL IV Abbreviation CDU: Crude Distillation Unit VDU: Vacuum Distillatioli Unit LP: Low Pressure EL: Battery Limit UC: Utility connection
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 36.
STEAM GENERATION START-UP/SHUTDOWN Document Number
Description
SA-JER-DS011-TRJR-400006
STEAM GENERATION START-UP/SHUTDOWN
Rev. 01
ORIGINAL SIGNED IN PROJECT FILE INTERMEDIATE PROCEDURE FOR
STEAM GENERATION START UP / SHUT DOWN UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0012 Date: 28‐NOV‐2011 Rev. : 01 Pag. : 1 of 15
DOCUMENT: SA‐JER‐DS011‐TRJR‐400006
INTERMEDIATE PROCEDURE FOR
STEAM GENERATION START UP / SHUT DOWM UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Note: This document does not replace the corresponding “Operating Procedure” or “OPERGUID” which will be developed by SATORP. REVISION CONTROL REV. 01 0
DATE 28‐NOV‐2011 03‐JUN‐2011
PREPARED BY Tulio Hernández
DISCIPLINE CODE PRO Document Class: 2
DESCRIPTION APPROVED FOR CONSTRUCTION ISSUE FOR REVIEW
CHECKED BY
APPROVED BY Juan Lechuga
Miguel A. Castro DOCUMENT TYPE MAN
UNIT 011
SYSTEM
Legend
Action o Verification ◊ Safety Action
B – Board Operator F– Field Operator S – Shift Supervisor
INTERMEDIATE PROCEDURE FOR
STEAM GENERATION START UP / SHUT DOWN UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0012 Date: 28‐NOV‐2011 Rev. : 01 Pag. : 2 of 15
LEVEL I LOGIC DIAGRAM
INITIAL STATE CDU / VDU UNIT under start‐up procedure.
100 STEAM GENERATION SYSTEM FILL‐UP
STABLE STATE S1 Steam drum and associated systems filled‐up with BFW
200 STEAM DRUM GENERATION START‐UP
STABLE STATE S2 Steam drum started‐up
300 STEAM GENERATION SHUT DOWN STABLE STATE S3 Steam generation shut down
400 STEAM GENERATION DRAINING
FINAL STATE Steam generation to Maintenance
INTERMEDIATE PROCEDURE FOR
STEAM GENERATION START UP / SHUT DOWN UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0012 Date: 28‐NOV‐2011 Rev. : 01 Pag. : 3 of 15
LEVEL I SUMMARY LOGIC DIAGRAM ........................................................................................................................................... 2 SUMMARY .................................................................................................................................................... 3 INITIAL STATE SHEET .................................................................................................................................... 4 100 STEAM GENERATION SYSTEM FILL‐UP ........................................................................................ 5 STABLE STATE 1 SHEET ................................................................................................................................. 6 200 STEAM DRUM GENERATION START‐UP ...................................................................................... 7 STABLE STATE 2 SHEET ................................................................................................................................. 9 300 STEAM GENERATION SHUT DOWN ........................................................................................... 10 STABLE STATE 3 SHEET ............................................................................................................................... 11 400 STEAM GENERATION DRAINING ............................................................................................... 12 FINAL STATE SHEET ..................................................................................................................................... 13
INTERMEDIATE PROCEDURE FOR
STEAM GENERATION START UP / SHUT DOWN UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0012 Date: 28‐NOV‐2011 Rev. : 01 Pag. : 4 of 15
LEVEL III INITIAL STATE SHEET INITIAL STATE CDU / VDU UNIT under start‐up procedure. DESCRIPTION o CDU unit is under started‐up procedure. Note: Prior to send product to vacuum residue to Slop & CDU/VDU long recirculation, the steam generation systems, steam drum D‐0011 and associated system shall be filled‐up with BFW and ready for start‐up. Refer to step 570 for IP‐0002 “CDU/VDU START‐UP”. o Prior to send product to vacuum residue, the steam drum D‐0011 and system shall be filled‐ up with BFW and ready for start‐up o All the blinds have been removed and located in the start‐up position. o Safety relief valves have been tested and installed. Isolation inlet valve to PZV‐0028 is lined‐up. o All instruments, analyzers and control of the steam generator systems are ready for service. o Vent and drains valves are in closed position. Note: The steam consumption of the heater F‐0002 is taken from battery limit through pressure valve PV‐0332 in manual mode. UTILITIES o All utilities available. o Flare systems available. o BFW systems available. o Oily water system in service. MATERIAL o Bottle and cylinders to take samples are available. o Means of communications available (walky‐talkies). o Analyzers align to process. o Phosphate injection package X‐0006 ready for start‐up. SAFETY ◊ Extinguishers are in position and available. ◊ Steam hoses and monitor hoses are available. ◊ Fire water system, safety showers, gas sensors are available
INTERMEDIATE PROCEDURE FOR
Procedure No. 011‐IP‐0012
STEAM GENERATION START UP / SHUT DOWN
Date: 28‐NOV‐2011 Rev. : 01 Pag. : 5 of 15
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
LEVEL III ACTIONS 100
STEAM GENERATION SYSTEM FILL‐UP
Note: interlock ZC‐0373 shall be deactivated by this action. o (F) Verify that bypass exchangers block valves E‐0031A and B, located on lines 10”‐RES‐ 011040002 and 10”‐RES‐011040005, are open. o (F) Verify that manual block valve on inlet exchanger E‐0031A is closed. (F) Open the steam drum vent, located on vessel top. o (F) Verify that block valve on vessel bottom to oily water system is close. ◊ (F) Ensure that safety valves PZV‐0028 / 0029 are in service. (F) Close manual block valves on line 6”‐BFW‐011040002 (water to E‐0031B) and line 6”‐BFW‐ 011040001 (water to E‐0031A). (F) Close manual continuous and intermittent blow down valves. (B) Commission pressure control PC‐0094 in manual mode, and adjust set point in 0 %. (B) Open ZV‐0025. (B) Adjust LC‐0065 set point at 60% in order to fill the steam drum with BFW. (F) Open manual block valves on line 6”‐BFW‐011040002 (water to E‐0031B) and line 6”‐BFW‐ 011040001 (water to E‐0031A). (F) Verify systems fill‐up opening manual block valve on line to OSW, located downstream tube side exchanger E‐0031 A and B and confirm that exist liquid. (F) Close open vents. (B) Establish a level of 50 % in D‐0011. STABLE STATE S1 Steam drum and associated systems filled‐up with BFW.
INTERMEDIATE PROCEDURE FOR
Procedure No. 011‐IP‐0012
STEAM GENERATION START UP / SHUT DOWN
Date: 28‐NOV‐2011 Rev. : 01 Pag. : 6 of 15
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
LEVEL III STABLE STATE 1 SHEET STABLE STATE S1 Steam drum and associated systems filled‐up with BFW. DESCRIPTION o Steams drum system fill‐up with BFW. UTILITIES o All utilities available. o Oily water system in service. o Storage tanks prepared to send vacuum residue to CDU/VDU unit. o Desuperheater DS‐0002 in normal operations, temperature control valve TV‐0049 in auto mode with set point 350 ºC. o Phosphate package injection ready for start up. MATERIAL o Means of communications available (walky‐talkies). o Bottle and cylinders to take samples are available. o Analyzers align to process. o Phosphate injection package X‐0006 ready for start‐up. SAFETY ◊ Extinguishers are in position and available. ◊ Steam hoses and monitor hoses are available. ◊ Fire water system, safety showers, gas sensors are available
INTERMEDIATE PROCEDURE FOR
STEAM GENERATION START UP / SHUT DOWN UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0012 Date: 28‐NOV‐2011 Rev. : 01 Pag. : 7 of 15
LEVEL III ACTIONS 200
STEAM DRUM GENERATION START‐UP
o (F) Verify that manual block valve on line 16”‐RES‐011099003‐103CS1P‐S (to slop & recirculation) is open. o (F) Verify that manual block valve on line 10”‐RES‐011010003‐103CS1P‐S (vacuum residue to Coker unit 021) is closed. o (F) Verify that two manual block valve on line 10”‐RES‐011099004‐103CS1P‐H (Line for VDU bypass) are closed. o (F) Verify that manual block valve on battery limit line 16”‐RES‐011040006‐103CS1P‐S (vacuum residue to storage unit 661) is closed. (B) Commission the flow control FC‐0053 located downstream exchanger E‐0031B (shell side), in manual mode and closed output 0%. (B) Commission the flow control FC‐0052 located on line of vacuum residue from Coker unit, in manual mode and closed output 0%.. (B) Commission temperature control valve TV‐0175, located in bypass E‐0031B line, in auto mode and adjust temperature set point at 180 ºC. o (F) Verify that control valves TV‐0175, FV‐0052 and FV‐0053 manual bypass are closed. (F) Open manual block valves (gate and butterfly valves) on line 6”‐BFW‐011040002 (water to E‐ 0031B) and line 6”‐BFW‐011040001 (water to E‐0031A). (F) Establish a level of boiler feed water in LPS generators E‐0031A/B. o (F) Verify all tubes are completely submerged with BFW, opening vent. o (B) Verify that level on D‐0011 is 50%. (F) Start phosphate injection in make‐up BFW inlet line to D‐0011 (3”‐BFW‐011040302‐ 101CS1P‐P). (F) Open slowly continuous blow down manual valve, approximately 5%. o (F) Verify liquid level on blow down drum D‐0013. o (F) Verify that manual block valves located downstream exchangers E‐0031A and B tube side (lines 12”‐LPS‐011040002‐101CS1P‐H and 12”‐LPS‐011040003‐101CS1P‐H), are open. (F) Open completely manual block valve of service water to blow down water from D‐0013 to OSW. (F) Open 5% globe valve located in the same line of service water. (F) Verify bypass manual valves of pressure control valves PV‐0094 A (steam to heater F‐0002) and PV‐0094B (steam for atmosphere) are closed. (B) Commission the drum D‐0011 pressure control PC‐0094 in split range and adjust pressure set point at 2.6 barg. (F) Open manual inlet and outlet valve of both exchangers E‐0031A/B shell side (10”‐RES‐ 011040001‐103CS1P‐S). (F) Close bypass exchangers E‐0031A and B manual valves. (B) Commission the flow control FC‐0053, in auto mode and adjust flow as requested. (B) Confirm pressure increase on steam generation drum D‐0011 (PI‐0095; PI‐0382). (B) Commission pressure control valves PV‐0094 A and B in the steam Drum D‐0011.
INTERMEDIATE PROCEDURE FOR
STEAM GENERATION START UP / SHUT DOWN UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0012 Date: 28‐NOV‐2011 Rev. : 01 Pag. : 8 of 15
(B) Set pressure control PV‐0094 A and B (2.6 barg) and pressure in cascade mode. LP steam will be vented through PV‐0094B at safe location. F) Regulate vapor flow generated closing slowly butterfly manual valves, located on inlet line to exchangers E‐0031 A and B (SP‐0002 and SP‐0003). (B) Confirmed pressure operation on D‐0011 (PI‐0095; PI‐0382). Note: LP steam is produced by recovered heat from the vacuum residue streams (E‐0031 A/B). LP steam is generated at 140 ºC and 2.6 barg. (F) Open frequently intermittent blow down valve to avoid water impurities accumulation on vessel bottom by gravity. Typically, intermittent blow down valve should be opened during 15 sec. each hour (120 sec. per shift). Note: Is very important to maintain the continuous blow down (SP‐0001) to avoid the corrosion caused by impurities generated during the evaporation process. (B) Once the steam produced by steam generator is in stable operation, proceed to align to the vacuum heater and through the pressure control valve PV‐0332, when steam superheated temperature coming from the vacuum heater is around of 350 ºC, stripping steam injection can be started.
STABLE STATE S2 Steam drum started‐up
INTERMEDIATE PROCEDURE FOR
STEAM GENERATION START UP / SHUT DOWN UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0012 Date: 28‐NOV‐2011 Rev. : 01 Pag. : 9 of 15
LEVEL III
STABLE STATE 2 SHEET
STABLE STATE S2 Steam drum started‐up
Note: This stable state is really two different stable states: The one after the start‐up of the steam generator system and the one before the steam generator system shutdown. DESCRIPTION (After Start‐up of Steam Generator System) o Steam drum started‐up. DESCRIPTION (Before shutdown of Steam Generator System) o (F) G‐0018 vacuum residue pump is stopped. o (F) Vacuum residue has been stopped completely. UTILITIES o All utilities available. o Boling feed water system available. o Instrument air system available. o OWS in service. MATERIAL o Means of communications available (walky‐talkies). o Bottle and cylinders to take samples are available. o Analyzers align to process. SAFETY ◊ Extinguishers are in position and available. ◊ Steam hoses are available. ◊ Monitor hoses are available. ◊ Fire water system, safety showers, gas sensors are available
INTERMEDIATE PROCEDURE FOR
STEAM GENERATION START UP / SHUT DOWN UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0012 Date: 28‐NOV‐2011 Rev. : 01 Pag. : 10 of 15
LEVEL III ACTIONS 300
STEAM GENERATION SHUT DOWN
Note: Refer to intermediate procedure 011‐IP‐0003 CDU/VDU SHUT DOWN Section 300 for details. (F) Close manual block valves located exchangers E‐0031 A and B inlet and outlet valve also to be close and bypass valve to be open. Line. (F) Stop phosphate pumps G‐0037 A/B injection to BFW make‐up to D‐0011. (F) Close manual block valves in services water injection to bottom D‐0013.
STABLE STATE S3 Steam generation shut down
INTERMEDIATE PROCEDURE FOR
STEAM GENERATION START UP / SHUT DOWN UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0012 Date: 28‐NOV‐2011 Rev. : 01 Pag. : 11 of 15
LEVEL III STABLE STATE 3 SHEET STABLE STATE S3 Steam generation shut down DESCRIPTION o Steam generation shut down. UTILITIES o All utilities available. o Oily water system in service. SAFETY ◊ Extinguishers are in position and available. ◊ Steam hoses are available. ◊ Monitor hoses are available. ◊ Safety showers are available.
INTERMEDIATE PROCEDURE FOR
STEAM GENERATION START UP / SHUT DOWN UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0012 Date: 28‐NOV‐2011 Rev. : 01 Pag. : 12 of 15
LEVEL III ACTIONS 400
STEAM GENERATION DRAINING (B) Set pressure control valve PV‐0094A in manual mode and closed. (B) Set pressure control valve PV‐0094B in automatic mode. (B) Reduce slowly the pressure on D‐0011 by sent steam to atmosphere thought PV‐0094B. Start to reduce pressure up to 2.0 barg. (B) Set level control valve LV‐0065 in manual mode and closed. (F) Open 2” vent on top of D‐0011 directly to atmosphere and lines high points vents. If the opening of PV‐0094B is reduce less than 20 % opening, put the pressure controller PC‐0094 in manual and opening to30 %. (F) Open manual block valve located on drain line 2”‐BDH‐011040004‐101CS1P‐P to OWS. (F) Open continuous and intermittent blow down valves. (F) Open block valve on drain line located up/down stream control valve LV‐0065. (F) Open blind and block valve located bottom D‐0013 to OSW. (F) Open completely butterfly valve located on inlet exchangers line. (F) Open blind and block valve in low point located on water inlet line to E‐0031A/B (tube side 6”‐BFW‐011040002‐101CS1P‐H and 6”‐BFW‐011040001‐101CS1P‐H) to OSW. (F) Open block valve on downstream exchangers line tube side (3/4”‐LPS‐011040013‐101CS1P‐ H and 3/4”‐LPS‐011040014‐101CS1P‐H) to OSW. (F) Open and closed drain and vent of LG‐0064. (F) Confirm that vessel and associate lines are completely emptying. (F) Closed blinds located in nozzles A1, B2, B3, B4, B5, and blind in drain line 2”‐OSW‐ 011040305‐101CS1P‐N.
FINAL STATE Steam generation to Maintenance.
INTERMEDIATE PROCEDURE FOR
STEAM GENERATION START UP / SHUT DOWN UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0012 Date: 28‐NOV‐2011 Rev. : 01 Pag. : 13 of 15
LEVEL III FINAL STATE SHEET FINAL STATE Steam generation to Maintenance. DESCRIPTION o Steam generation systems ready for maintenance. o Closed drain with blind. o BFW make up with blind. o All purges are closed.
INTERMEDIATE PROCEDURE FOR
STEAM GENERATION START UP / SHUT DOWN UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0012 Date: 28‐NOV‐2011 Rev. : 01 Pag. : 14 of 15
LEVEL IV Abbreviation CDU: Crude Distillation Unit VDU: Vacuum Distillation Unit LP: Low Pressure MP: Medium Pressure HP: High Pressure HLL: High liquid level BFW: Boiler Feed water WWT: Waste Water Treatment NHDT: Naphtha Hydrotreater HDS: Hydrodesulphurisation DHC: Distillate Hydrocracker MHC: Mild Hydrocracker LAGO: Light Atmospheric Crude HAGO: Heavy Atmospheric Crude LVGO: Light Vacuum Crude MVGO: Medium Vacuum Crude HVGO: Heavy Vacuum Crude PA: Pumparound BL: Battery Limit UC: Utility connection OWS: Oily water system
INTERMEDIATE PROCEDURE FOR
STEAM GENERATION START UP / SHUT DOWN UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
BLIND LIST
Procedure No. 011‐IP‐0012 Date: 28‐NOV‐2011 Rev. : 01 Pag. : 15 of 15
CDU/VDU UNIT (UNIT 011) BLIND LIST Line number
P&ID
Service
2"‐HGO‐011099003‐103CS1P‐P 2"‐RES‐011099003‐103CS1P‐P 4"‐LPS‐011041004‐101CS1P‐P 2"‐LPS‐011041007‐101CS1P‐P 2"‐RES‐011040018‐103CS1P‐P 2"‐RES‐011040019‐103CS1P‐P 4"‐LPS‐011041003‐101CS1P‐P 3"‐AMN‐011099001‐103CS2D‐H 16"‐RES‐011040006‐103CS1P‐S 10"‐RES‐011010003‐103CS1P‐S 3"‐AMN‐011036004‐103CH2S‐P 2"‐HGO‐011099001‐103CS1P‐S 2"‐RES‐011099001‐103CS1P‐S 2"‐HGO‐011099002‐103CS1P‐S 8"‐HGO‐011038005‐103CS1P‐S 2"‐RES‐011099002‐103CS1P‐S 2"‐BDH‐011040004‐101CS1P‐P 2"‐SWA‐011040302‐101CS1P‐N 2"‐RES‐011040010‐103CS1P‐S 3/4"‐OSW‐011040302‐101CS1P‐N 2"‐RES‐011040003‐103CS1P‐P 3/4"‐OSW‐011040304‐101CS1P‐N 12"‐LPS‐011040003‐101CS1P‐H 10"‐RES‐011040003‐103CS1P‐S 2"‐RES‐011040012‐103CS1P‐S 10"‐RES‐011040006‐103CS1P‐S 2"‐RES‐011040002‐103CS1P‐P 2"‐RES‐011040009‐103CH2S‐S 2"‐RES‐011040008‐103CH2S‐S 2"‐RES‐011040011‐103CS1P‐S 3/4"‐OSW‐011040303‐101CS1P‐N 10"‐RES‐011040001‐103CS1P‐S 12"‐LPS‐011040002‐101CS1P‐H 3/4"‐LPS‐011040013‐101CS1P‐H 6"‐BFW‐011040001‐101CS1P‐H 2"‐RES‐011040005‐103CS1P‐P 2"‐RES‐011040001‐103CS1P‐P 10"‐RES‐011040003‐103CS1P‐S 6"‐BFW‐011040002‐101CS1P‐H 2"‐BDH‐011040005‐101CS1P‐P 3/4"‐OSW‐011040308‐101CS1P‐N 8"‐HGO‐011038004‐103CS1P‐S 2"‐SWA‐011040301‐101CS1P‐N 2"‐SWA‐011041301‐101CS1P‐N 3/4"‐OSW‐011040309‐101CS1P‐N 4"‐LPS‐011041003‐101CS1P‐P 6"‐LPS‐011040006‐101CS1P‐P 3"‐BFW‐011040302‐101CS1P‐P 10"‐LPS‐011040004‐101CS1P‐H 2"‐BDH‐011040002‐101CS1P‐P 2"‐BDH‐011040001‐101CS1P‐P 6"‐BFW‐011040002‐101CS1P‐H 6"‐BFW‐011040001‐101CS1P‐H 2"‐FLO‐011040307‐101CS1P‐N 2"‐RES‐011040015‐103CS1P‐S 2"‐RES‐011040016‐103CS1P‐S 6"‐SLP‐011099001‐103CS1P‐P 2"‐FLO‐011040306‐101CS1P‐N
DS011‐TRJR‐480138 DS011‐TRJR‐480138 DS011‐TRJR‐480106 DS011‐TRJR‐480106 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480106 DS011‐TRJR‐480137 DS011‐TRJR‐480138 DS011‐TRJR‐480137 DS011‐TRJR‐480137 DS011‐TRJR‐480137 DS011‐TRJR‐480137 DS011‐TRJR‐480138 DS011‐TRJR‐480138 DS011‐TRJR‐480138 DS011‐TRJR‐480105 DS011‐TRJR‐480105 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480105 DS011‐TRJR‐480104 DS011‐TRJR‐480137 DS011‐TRJR‐480105 DS011‐TRJR‐480106 DS011‐TRJR‐480104 DS011‐TRJR‐480106 DS011‐TRJR‐480105 DS011‐TRJR‐480105 DS011‐TRJR‐480105 DS011‐TRJR‐480105 DS011‐TRJR‐480105 DS011‐TRJR‐480105 DS011‐TRJR‐480105 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480138 DS011‐TRJR‐480104
HEAVY GAS OIL RESIDUE LP STEAM LP STEAM VACUUM RESIDUE VACUUM RESIDUE LP STEAM LEAN AMINE VACUUM RESIDUE VACUUM RESIDUE RICH AMINE HVGO VACUUM RESIDUE HVGO HVGO VACUUM RESIDUE WATER SERVICE WATER VACUUM RESIDUE WATER RESIDUE WATER LP STEAM VACUUM RESIDUE VACUUM RESIDUE VACUUM RESIDUE RESIDUE VACUUM RESIDUE VACUUM RESIDUE VACUUM RESIDUE WATER VACUUM RESIDUE LP STEAM LP STEAM BOILER FEED WATER RESIDUE RESIDUE VACUUM RESIDUE BOILER FEED WATER WATER WATER HVGO SERVICE WATER SERVICE WATER WATER LP STEAM LP STEAM BOILER FEED WATER LP STEAM WATER WATER BOILER FEED WATER BOILER FEED WATER FLUSHING OIL VACUUM RESIDUE VACUUM RESIDUE SLOP OIL FLUSHING OIL
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 37.
TEMPERED WATER SYSTEM GASSING/ START-UP/ SHUTDOWN/ DEGASSING Document Number
Description
SA-JER-DS011-TRJR-400007
TEMPERED WATER SYSTEM GASSING/STARTUP/SHUTDOWN/DEGASSING
Rev. 01
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 38.
CLOSE DRAIN GASSING/ START UP/ SHUTDOWN/ DEGASSING Document Number
Description
SA-JER-DS011-TRJR-409228
CLOSE DRAIN GASSING/START-UP/SHUTDOWN/DEGASSING
Rev. 01
INTERMEDIATE PROCEDURE FOR
Procedure No. 011‐IP‐0017
CLOSED DRAIN P.O Date: 17‐Aug‐2011 SHUTDOWN/DEGASSING/ Rev. : 01 GASSING/START‐UP Pag. : 1 of 27
UNIT 011 – CDU/VDU
ORIGINAL SIGNED IN PROJECT FILE
DOCUMENT: SA‐JER‐DS011‐TRJR‐409228
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP UNIT 011 – CDU/VDU
Note: This document does not replace the corresponding “Operating Procedure” or “OPERGUID” which will be developed by SATORP. REVISION CONTROL REV. 00 01
DATE 30‐05‐2011 17‐08‐2011
DESCRIPTION ISSUE FOR REVIEW ISSUE FOR APPROVAL
DISCIPLINE CODE COM Document Class: 2
DOCUMENT TYPE MAN
UNIT 011
SYSTEM
Legend
Action o Verification ◊ Safety Action
B – Board Operator F – Field Operator S – Shift Supervisor
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 2 of 27
UNIT 011 – CDU/VDU
LEVEL I SUMMARY SUMMARY .................................................................................................................................................... 2 LOGIC DIAGRAM ........................................................................................................................................... 3 SHUTDOWN INITIAL STATE SHEET ................................................................................................................ 4 100 SHUTDOWN CLD SYSTEM ................................................................................................................ 5 110 PRELIMINARY CHECKS .................................................................................................................. 5 120 DEGASSING .................................................................................................................................. 6 130 BLINDS IN CLOSED DRAIN DRUM 011‐D‐0014 ............................................................................. 6 SHUTDOWN FINAL STATE SHEET .................................................................................................................. 7 START‐UP INITIAL STATE SHEET .................................................................................................................... 8 200 START‐UP OF CLD SYSTEM ............................................................................................................... 9 210 PRELIMINARY CHECKS .................................................................................................................. 9 220 GASSING ..................................................................................................................................... 10 START‐UP FINAL STATE SHEET .................................................................................................................... 11 BLIND LIST ANNEX CLOSED DRAIN SYSTEM ................................................................................................ 12
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 3 of 27
UNIT 011 – CDU/VDU
LEVEL I LOGIC DIAGRAM SHUTDOWN INITIAL STATE CLOSED DRAIN SYSTEM in normal operation. Unit 011 shut, purged, fluidised and liquid drained.
100 SHUTDOWN CLD SYSTEM
SHUTDOWN FINAL STATE
CLOSED DRAIN SYSTEM is isolated, steamed out, HC free. Work Permit to enter in the CLD drum has been issued.
START‐UP INITIAL STATE
Unit 011 and CLD have been taken over from Maintenance. CLD is blocked and blinded. 200 START‐UP OF CLD SYSTEM
START‐UP FINAL STATE
CLOSED DRAIN SYSTEM is ready to receive liquids.
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 4 of 27
UNIT 011 – CDU/VDU
LEVEL III SHUTDOWN INITIAL STATE SHEET
SHUTDOWN INITIAL STATE CLOSED DRAIN SYSTEM in normal operation. Unit 011 shut, purged, fluidized and liquid drained. DESCRIPTION o All spectacle blinds are in normal position as per related P&ID´s. o The unit was shut and has been fluidised with FLO, as needed. o Equipment with UC has been steamed/inerted to CLD as needed. o CLD in normal operation. o FLO in normal operation. SAFETY ◊ Extinguishers are in position and available. ◊ Steam hoses are available. ◊ Monitor hoses are available. ◊ Safety showers and rinsing facilities are available. ◊ Snuffing steam ready. ◊ Fire water system ready. ◊ Escape root clear. ◊ House Keeping OK. ◊ Assembly point clear. ◊ Use Personnel Protection Equipment. ◊ Communication system OK.
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 5 of 27
UNIT 011 – CDU/VDU
LEVEL III ACTIONS
100 SHUTDOWN CLD SYSTEM
110 PRELIMINARY CHECKS
o (F) Check all the process equipments have been drained to CLD, according with the unit 011 Shutdown General Procedure. (S) Make turn to open position following blinds: 9 7852‐2”‐FLO (P&ID‐480216) 9 7871‐2”‐FLO (P&ID‐480230) 9 7853‐2”‐FLO (P&ID‐480230) 9 7832‐2”‐FLO (P&ID‐480231) 9 2211‐2”‐FLO (P&ID‐480231) 9 7870‐2”‐FLO (P&ID‐480230) 9 7835‐2”‐FLO (P&ID‐480231) (F) Open block valve to flush with FLO in the following points to 011‐D‐0014 Closed Drain Drum: 9 7852‐2”‐FLO 9 7871‐2”‐FLO 9 7853‐2”‐FLO 9 7832‐2”‐FLO 9 2211‐2”‐FLO 9 7870‐2”‐FLO 9 7835‐2”‐FLO
(S) Make turn to close position following blinds: 9 7852‐2”‐FLO 9 7871‐2”‐FLO 9 7853‐2”‐FLO 9 7832‐2”‐FLO 9 2211‐2”‐FLO 9 7870‐2”‐FLO 9 7835‐2”‐FLO o (F) Check all the equipments have blinds according with their blind list. o (F) Check all the equipments have in CLOSE position their blinds to CLD. o (F) Check is in open position LPS to 011‐D‐0014 and the condensate steam trap. o (F) Check 011‐LI‐0083/011‐LI‐0084. o (F) Check 011‐TI‐0262.
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 6 of 27
UNIT 011 – CDU/VDU
LEVEL III 120 DEGASSING
(F) Close two 6”valves CLD from Header to the inlet of 011‐D‐0014. (F) Start 011‐G‐0025 if necessary, until Low level in 011‐LL‐0084. (F) Connect a portable pump in 4” flange to remove deeper liquids and connect the discharge to the discharge line of 011‐G‐0025A, drain before blind. (F) Start this portable pump if necessary. o (F) Check 011‐LI‐0083/011‐LI‐0084. (S) Make swing to open position 2” blind in the UC to 011‐D‐0014. o (F) Check if is in open position blind of 011‐D‐0014 to LP Flare. (F) Connect a steam hose in the UC Steam and inject LPS to 011‐D‐0014 sending the vapour to LP Flare. (F) Remove condensate with portable pump, sending to Slop Oil. o (F) Check the colour in the condensate to Slop Oil in order to stop the steaming. 130 BLINDS IN CLOSED DRAIN DRUM 011‐D‐0014
(S) Make swing to close position the following blinds:
9 Discharge of 011‐G‐0025A 9 2141‐6”‐LPF
(F) Open 6” vent to the atmosphere. (F) Steam out 011‐D‐0014 to the atmosphere. (F) Block 2”‐LPS to 011‐D‐0014. (S) Make turn to close position blind in the LPS to 011‐D‐0014. (F) Block steam trap of condensate from 011‐D‐0014. (S) Make turn to close position blind in the condensate 22 from 011‐D‐0014. (F) Open two 24” flanges to the atmosphere. (F) Inject air through one 24” flanges, leaving 011‐D‐0024 by a far away 24” flange to the atmosphere. (F) Maintain this circulation at least 24 hours. o (F) Check Oxygen, HC analysis in 011‐D‐0014. o (F) Check temperature in 011‐D‐0014 with 011‐TI‐0262. (S) Issue work permit to enter in 011‐D‐0014 according with the Refinery Work Permit System. THIS PROCEDURE HAS ONLY CONSIDERED SOME KIND OF MAINTENANCE SHOULD BE DONE IN 011‐D‐0024 OR 011‐G‐0025A, NOT IN THE CLD lines to 011‐D‐0024 or discharge line of 011‐G‐0025A, as these activities has a low likelihood of maintenance. SHUTDOWN FINAL STATE CLOSED DRAIN SYSTEM is isolated, steamed out, HC free. Work Permit to enter in the CLD drum has been issued.
INTERMEDIATE PROCEDURE FOR
Procedure No. 011‐IP‐0017
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Date: 17‐Aug‐2011 Rev. : 01 Pag. : 7 of 27
UNIT 011 – CDU/VDU
LEVEL III SHUTDOWN FINAL STATE SHEET SHUTDOWN FINAL STATE CLOSED DRAIN SYSTEM is isolated, steamed out, HC free. Work Permit to enter in the CLD drum has been issued. DESCRIPTION o All spectacle blinds are in normal position as per related P&ID´s. o The unit has been fluidised with FLO as needed. o 011‐D0014 has been liquid removed, steamed and HC free. o 011‐D‐0014 has been isolated by blinds. o A work permit has been issued to enter in 011‐D0014. SAFETY ◊ Extinguishers are in position and available. ◊ Steam hoses are available. ◊ Monitor hoses are available. ◊ Safety showers and rinsing facilities are available. ◊ Snuffing steam ready. ◊ Fire water system ready. ◊ Escape root clear. ◊ House Keeping OK. ◊ Assembly point clear. ◊ Use Personnel Protection Equipment. ◊ Communication system OK.
INTERMEDIATE PROCEDURE FOR
Procedure No. 011‐IP‐0017
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Date: 17‐Aug‐2011 Rev. : 01 Pag. : 8 of 27
UNIT 011 – CDU/VDU
LEVEL III START‐UP INITIAL STATE SHEET START‐UP INITIAL STATE Unit 011 and CLD have been taken over from Maintenance. CLD is blocked and blinded.
DESCRIPTION o Unit 011 is shut. o All spectacle blinds are in normal position as per related P&ID´s. o 011‐D‐0014 open to the atmosphere. o All blinds in 011‐D‐0014 according with Maintenance position in the blind list. o Flare system is available
SAFETY ◊ Extinguishers are in position and available. ◊ Steam hoses are available. ◊ Monitor hoses are available. ◊ Safety showers and rinsing facilities are available. ◊ Snuffing steam ready. ◊ Fire water system ready. ◊ Escape root clear. ◊ House Keeping OK. ◊ Assembly point clear. ◊ Use Personnel Protection Equipment. ◊ Communication system OK.
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 9 of 27
UNIT 011 – CDU/VDU
LEVEL III ACTIONS
200 START‐UP OF CLD SYSTEM 210 PRELIMINARY CHECKS
o
(F) Check the blinds and flanges are in the following position:
MAINTENANCE
NORMAL OPERATION
5334‐6”‐CLD FROM HEADER
CLOSE
OPEN
2141‐6”‐LPF
CLOSE
OPEN
4” Discharge of 011‐G‐0025A
CLOSE
OPEN
2”‐UC
CLOSE
CLOSE
5337‐2”‐LPS
CLOSE
CLOSE
Two 4” vents
OPEN
CLOSE
6”‐vents
OPEN
CLOSE
Four 24”‐Manhole
OPEN
CLOSE
BLINDS AND FLANGES
o o
(F) Make check all the instruments works properly in 011‐D‐0014. (F) Make check 011‐G‐0025A is energized.
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 10 of 27
UNIT 011 – CDU/VDU
LEVEL III 220 GASSING (S) Make turn to close position two 24” flanges of 011‐D‐0014 to the atmosphere. (F) Check all the vents of 011‐D‐0014 to the atmosphere are closed and their flanges are in close position (F) Connect a nitrogen hose in UC. (F) Open ¾” vent in LPF before the block valve. (F) Open 1” drain in the discharge line of 011‐G‐0025A. (F) Open nitrogen to 011‐D‐0014. (F) When oxygen is lower than 0.5% vol, close nitrogen hose. (F) Disconnect nitrogen hose. (F) Make turn to close position blind in the UC to 011‐D‐0014. (S) Make swing to the open position blind in CLD FROM HEADER to 011‐D‐0014. (S) Make swing to open position blinds in 011‐D‐0014 according with normal situation in Operation (See Blinds and flanges, page before). (F) Open nitrogen to 011‐D‐0014 and make a leak test according with the Operating Procedures. (F) Close:
9 9
¾ vent in the LPF 1” in the discharge of 011‐G‐0025A
(S) Make turn to open position blinds in LPS and LPC to 011‐D‐0014. (F) Open 6” valve to LPF. (F) Open steam trap of 011‐D‐0014. Open 2”‐LPS. (F) Open two 6” valves CLD FROM HEADER to 011‐D‐0014. (F) Open discharge block valve of 011‐G‐0025A.
START‐UP FINAL STATE
CLOSED DRAIN SYSTEM is ready to receive liquids.
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 11 of 27
UNIT 011 – CDU/VDU
LEVEL III START‐UP FINAL STATE SHEET START‐UP FINAL STATE CLOSED DRAIN SYSTEM is ready to receive liquids. DESCRIPTION o All spectacle blinds are in normal position as per related P&ID´s. o The unit 011 is shut. o Flare system is available. o CLD SYSTEM, has been inerted and air free. All the blinds according with the normal situation for operation. o CLD SYSTEM is ready to receive liquids.
SAFETY ◊ Extinguishers are in position and available. ◊ Steam hoses are available. ◊ Monitor hoses are available. ◊ Safety showers and rinsing facilities are available. ◊ Snuffing steam ready. ◊ Fire water system ready. ◊ Escape root clear. ◊ House Keeping OK. ◊ Assembly point clear. ◊ Use Personnel Protection Equipment. ◊ Communication system OK.
INTERMEDIATE PROCEDURE FOR
Procedure No. 011‐IP‐0017
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Date: 17‐Aug‐2011 Rev. : 01 Pag. : 12 of 27
UNIT 011 – CDU/VDU
LEVEL IV BLIND LIST ANNEX CLOSED DRAIN SYSTEM NORMAL OPERATION
MAINTENANCE
480001 2”‐ CLD‐011001307‐101CH2S‐N
CLOSE
CLOSE
480002 2”‐CLD‐011001309‐101CH2S‐N
CLOSE
CLOSE
2"‐CLD‐011001308‐101CH2S‐N
CLOSE
CLOSE
480003 2"‐CLD‐011001310‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011001312‐101CH2S‐P
CLOSE
CLOSE
480004 2”‐CLD‐011002306‐101CH2S‐N
CLOSE
CLOSE
2"‐CLD‐011002307‐101CH2S‐N
CLOSE
CLOSE
2"‐CLD‐011002305‐101CH2S‐N
CLOSE
CLOSE
2"‐CLD‐011002301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011002303‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011002302‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011002304‐101CH2S‐P
CLOSE
CLOSE
480005 2” ‐CLD‐011003302‐101CH2S‐P
CLOSE
CLOSE
P&ID´S
BLIND
2"‐CLD‐011003301‐101CH2S‐P
CLOSE
CLOSE
2” ‐CLD‐011003313‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011003314‐101CH2S‐P
CLOSE
CLOSE
2” ‐CLD‐011003304‐101CH2S‐P
CLOSE
CLOSE
2” ‐CLD‐011003303‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011003305‐101CH2S‐P
CLOSE
CLOSE
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 13 of 27
UNIT 011 – CDU/VDU
480006 2"‐CLD‐011003309‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011003310‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011003312‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011003315‐101CH2S‐P
CLOSE
CLOSE
480007 2"‐CLD‐011004310‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011004307‐101CH2S‐P
CLOSE
CLOSE
480008 2"‐CLD‐011004305‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011004306‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011004309‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐101‐011004311CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011004302‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011004301‐101CH2S‐P
CLOSE
CLOSE
480009 2"‐CLD‐011005307‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011005308‐101CH2S‐P
CLOSE
CLOSE
480010 2"‐CLD‐011005301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011005305‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011005302‐101CH2S‐P
CLOSE
CLOSE
2”‐CLD‐011005306‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011005312‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011005311‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011005309‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011006301‐101CH2S‐P
CLOSE
CLOSE
480011 4"‐CLD‐011006302‐101CH2S‐P
CLOSE
CLOSE
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 14 of 27
UNIT 011 – CDU/VDU
2"‐CLD‐011006306‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011006308‐101CH2S‐P
CLOSE
CLOSE
480012 4"‐CLD‐011007302‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011007308‐101CH2S‐P
CLOSE
CLOSE
480013 2"‐CLD‐011007301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011007303‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011007304‐101CH2S‐P
CLOSE
CLOSE
480015 2"‐CLD‐011008303‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011008304‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011008309‐101CH2S‐P
CLOSE
CLOSE
480016 2"‐CLD‐011008305‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011008306‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011008307‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011008308‐101CH2S‐P
CLOSE
CLOSE
480017 2"‐CLD‐011009301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011009302‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011009303‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011009304‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011009305‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011009306‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011009308‐101CH2S‐P
CLOSE
CLOSE
480018 2"‐CLD‐011010301‐101CH2S‐P
CLOSE
CLOSE
CLOSE
CLOSE
2"‐CLD‐011010304‐101CH2S‐P
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 15 of 27
UNIT 011 – CDU/VDU
2"‐CLD‐011010305‐101CH2S‐P
CLOSE
CLOSE
480019 2"‐CLD‐011010302‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011010303‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011010306‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011010307‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011010308‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011010309‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011010311‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011010312‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011010313‐101CH2S‐P
CLOSE
CLOSE
480020 6"‐CLD‐011011301‐101CH2S‐P
CLOSE
CLOSE
480021 2"‐CLD‐011011301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011011302‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011011303‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011011304‐101CH2S‐P
CLOSE
CLOSE
480022 2"‐CLD‐011012301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011012302‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011012303‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011012306‐101CH2S‐N
CLOSE
CLOSE
480023 2"‐CLD‐011012305‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011012304‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011012307‐101CH2S‐P
CLOSE
CLOSE
480024 2"‐CLD‐011013312‐101CH2S‐P
CLOSE
CLOSE
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 16 of 27
UNIT 011 – CDU/VDU
2"‐CLD‐011013313‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011013314‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011013302‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011013315‐101CH2S‐P
CLOSE
CLOSE
480025 2"‐CLD‐011013303‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011013304‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011013317‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011013305‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011013306‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011013319‐101CH2S‐P
CLOSE
CLOSE
480026 2"‐CLD‐011014301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011014302‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011014303‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011014304‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011014305‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011014306‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011014313‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011014314‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011014315‐101CH2S‐P
CLOSE
CLOSE
480027 2"‐CLD‐011014307‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011014308‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011014309‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011014310‐101CH2S‐P
CLOSE
CLOSE
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 17 of 27
UNIT 011 – CDU/VDU
2"‐CLD‐011014311‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011014312‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011014316‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011014317‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011014319‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011014320‐101CH2S‐P
CLOSE
CLOSE
480028 2"‐CLD‐011015301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015302‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015303‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015304‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015305‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015306‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015307‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015308‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015317‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015318‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015319‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015320‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015321‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015322‐101CH2S‐P
CLOSE
CLOSE
480029 2"‐CLD‐011015309‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015310‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015311‐101CH2S‐P
CLOSE
CLOSE
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 18 of 27
UNIT 011 – CDU/VDU
2"‐CLD‐011015312‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015313‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015314‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015315‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015316‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015323‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015324‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015325‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015326‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015327‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011015328‐101CH2S‐P
CLOSE
CLOSE
480030 2"‐CLD‐011016301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011016302‐101CH2S‐P
CLOSE
CLOSE
480031 2"‐CLD‐011016303‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011016304‐101CH2S‐P
CLOSE
CLOSE
480032 2"‐CLD‐011016305‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011016306‐101CH2S‐P
CLOSE
CLOSE
480033 2"‐CLD‐011016307‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011016308‐101CH2S‐P
CLOSE
CLOSE
480034 2"‐CLD‐011017301‐101CH2S‐P
CLOSE
CLOSE
480035 2"‐CLD‐011017302‐101CH2S‐P
CLOSE
CLOSE
480036 2"‐CLD‐011017303‐101CH2S‐P
CLOSE
CLOSE
480037 2"‐CLD‐011017304‐101CH2S‐P
CLOSE
CLOSE
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 19 of 27
UNIT 011 – CDU/VDU
480038 2"‐CLD‐011017305‐101CH2S‐P
CLOSE
CLOSE
480039 2"‐CLD‐011017306‐101CH2S‐P
CLOSE
CLOSE
480040 2"‐CLD‐011017307‐101CH2S‐P
CLOSE
CLOSE
480041 2"‐CLD‐011017308‐101CH2S‐P
CLOSE
CLOSE
480043 2"‐CLD‐011018306‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011018308‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011018301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011018315‐101CH2S‐P
CLOSE
CLOSE
48044 2"‐CLD‐011018303‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011018304‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011018307‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011018309‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011018310‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011018312‐101CH2S‐P
CLOSE
CLOSE
480045 2"‐CLD‐011019306‐101CH2S‐P
CLOSE
CLOSE
480046 2"‐CLD‐011019308‐101CH2S‐N
CLOSE
CLOSE
2"‐CLD‐011019309‐101CH2S‐P
CLOSE
CLOSE
4"‐CLD‐011019301‐101CH2S‐P
CLOSE
CLOSE
480047 2"‐CLD‐011019302‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011019303‐101CH2S‐P
CLOSE
CLOSE
480048 2"‐CLD‐011020301‐101CH2S‐P
CLOSE
CLOSE
480050 2"‐CLD‐011021305‐101CH2S‐N
CLOSE
CLOSE
CLOSE
CLOSE
4"‐CLD‐011021301‐101CH2S‐N
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 20 of 27
UNIT 011 – CDU/VDU
480051 2"‐CLD‐011021302‐101CH2S‐N
CLOSE
CLOSE
480052 2"‐CLD‐011022305‐101CH2S‐P
CLOSE
CLOSE
4"‐CLD‐011022303‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011022304‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011022302‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011022306‐101CH2S‐P
CLOSE
CLOSE
3"‐CLD‐011022301‐101CH2S‐P
CLOSE
CLOSE
480053 2"‐CLD‐011022307‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011022308‐101CH2S‐P
CLOSE
CLOSE
480054 2"‐CLD‐011023301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011023302‐101CH2S‐P
CLOSE
CLOSE
480055 2"‐CLD‐011023303‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011023304‐101CH2S‐P
CLOSE
CLOSE
480056 2"‐CLD‐011024301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011024304‐101CH2S‐P
CLOSE
CLOSE
480057 2"‐CLD‐011024302‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011024303‐101CH2S‐P
CLOSE
CLOSE
480058 2"‐CLD‐011025301‐101CH2S‐N
CLOSE
CLOSE
2"‐CLD‐011025302‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011025313‐101CH2S‐P
CLOSE
CLOSE
480060 2"‐CLD‐011025303‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011025304‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011025315‐101CH2S‐P
CLOSE
CLOSE
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 21 of 27
UNIT 011 – CDU/VDU
480061 2"‐CLD‐011025316‐101CH2S‐P
CLOSE
CLOSE
480062 2"‐CLD‐011025305‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011025306‐101CH2S‐P
CLOSE
CLOSE
480063 2"‐CLD‐011026301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011026302‐101CH2S‐P
CLOSE
CLOSE
480064 2"‐CLD‐011026303‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011026304‐101CH2S‐P
CLOSE
CLOSE
480065 2"‐CLD‐011027301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011027302‐101CH2S‐P
CLOSE
CLOSE
480066 2"‐CLD‐011027303‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011027304‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011027305‐101CH2S‐P
CLOSE
CLOSE
4"‐CLD‐011027306‐101CH2S‐P
CLOSE
CLOSE
4"‐CLD‐011027307‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011027308‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011027309‐101CH2S‐P
CLOSE
CLOSE
480067 2"‐CLD‐011028301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011028302‐101CH2S‐P
CLOSE
CLOSE
480068 2"‐CLD‐011028303‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011028304‐101CH2S‐P
CLOSE
CLOSE
480069 2"‐CLD‐011028305‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011028306‐101CH2S‐P
CLOSE
CLOSE
480070 2"‐CLD‐011028307‐101CH2S‐P
CLOSE
CLOSE
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 22 of 27
UNIT 011 – CDU/VDU
2"‐CLD‐011028308‐101CH2S‐P
CLOSE
CLOSE
480071 2"‐CLD‐011029301‐101CH2S‐P
CLOSE
CLOSE
480072 2"‐CLD‐011029302‐101CH2S‐P
CLOSE
CLOSE
480073 2"‐CLD‐011029303‐101CH2S‐P
CLOSE
CLOSE
480074 2"‐CLD‐011029304‐101CH2S‐P
CLOSE
CLOSE
480075 2"‐CLD‐011029305‐101CH2S‐P
CLOSE
CLOSE
480076 2"‐CLD‐011029306‐101CH2S‐P
CLOSE
CLOSE
480077 2"‐CLD‐011029307‐101CH2S‐P
CLOSE
CLOSE
480078 2"‐CLD‐011029308‐101CH2S‐P
CLOSE
CLOSE
480080 2"‐CLD‐011030301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011030302‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011030305‐101CH2S‐N
CLOSE
CLOSE
480081 2"‐CLD‐011030303‐101CH2S‐P
CLOSE
CLOSE
4"‐CLD‐011030304‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011030307‐101CH2S‐P
CLOSE
CLOSE
480086 2"‐CLD‐011033301‐101CH2S‐N
CLOSE
CLOSE
2"‐CLD‐011033307‐101CH2S‐N
CLOSE
CLOSE
3"‐CLD‐011033308‐101CH2S‐N
CLOSE
CLOSE
2"‐CLD‐011033311‐101CH2S‐N
CLOSE
CLOSE
480087 2"‐CLD‐011033302‐101CH2S‐N
CLOSE
CLOSE
2"‐CLD‐011033303‐101CH2S‐N
CLOSE
CLOSE
2"‐CLD‐011033304‐101CH2S‐N
CLOSE
CLOSE
2"‐CLD‐011033305‐101CH2S‐N
CLOSE
CLOSE
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 23 of 27
UNIT 011 – CDU/VDU
2"‐CLD‐011033306‐101CH2S‐N
CLOSE
CLOSE
480088 2"‐CLD‐011033309‐101CH2S‐N
CLOSE
CLOSE
2"‐CLD‐011033310‐101CH2S‐N
CLOSE
CLOSE
2"‐CLD‐011033312‐101CH2S‐N
CLOSE
CLOSE
480089 2"‐CLD‐011034301‐101CH2S‐N
CLOSE
CLOSE
480090 2"‐CLD‐011034302‐101CH2S‐N
CLOSE
CLOSE
2"‐CLD‐011034303‐101CH2S‐N
CLOSE
CLOSE
480091 2"‐CLD‐011035301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011035302‐101CH2S‐N
CLOSE
CLOSE
480093 2"‐CLD‐011036301‐101CH2S‐N
CLOSE
CLOSE
2"‐CLD‐011036302‐101CH2S‐N
CLOSE
CLOSE
480096 2"‐CLD‐011037301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011037302‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011037303‐101CH2S‐P
CLOSE
CLOSE
480097 2"‐CLD‐011037308‐101CH2S‐P
CLOSE
CLOSE
480098 2"‐CLD‐011037004‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011037309‐101CH2S‐P
CLOSE
CLOSE
480099 2"‐CLD‐011038301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011038302‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011038303‐101CH2S‐P
CLOSE
CLOSE
480100 2"‐CLD‐011038304‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011038307‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011038308‐101CH2S‐P
CLOSE
CLOSE
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 24 of 27
UNIT 011 – CDU/VDU
CLOSE
CLOSE
2"‐CLD‐011039302‐101CH2S‐P
CLOSE
CLOSE
480102 2"‐CLD‐011039303‐101CH2S‐P
CLOSE
CLOSE
480101 2"‐CLD‐011039301‐101CH2S‐P
2"‐CLD‐011039304‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011039305‐101CH2S‐P
CLOSE
CLOSE
480103 2"‐CLD‐011039306‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011039307‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011039308‐101CH2S‐P
CLOSE
CLOSE
480104 2"‐CLD‐011040301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011040302‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011040303‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011040307‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011040308‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011040310‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011040311‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011040312‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011040313‐101CH2S‐P
CLOSE
CLOSE
480107 2"‐CLD‐011042302‐101CH2S‐P
CLOSE
CLOSE
480108 2"‐CLD‐011042303‐101CH2S‐N
CLOSE
CLOSE
480109 2"‐CLD‐011042301‐101CH2S‐P
CLOSE
CLOSE
480110 2"‐CLD‐011043301‐101CH2S‐P
CLOSE
CLOSE
480113 3"‐CLD‐011044301‐101CH2S‐N
CLOSE
CLOSE
480114 2"‐CLD‐011044302‐101CH2S‐N
CLOSE
CLOSE
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 25 of 27
UNIT 011 – CDU/VDU
2"‐CLD‐011044303‐101CH2S‐N
CLOSE
CLOSE
2"‐CLD‐011044304‐101CH2S‐N
CLOSE
CLOSE
480132 2"‐CLD‐011098302‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011098317‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011098319‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011098324‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011098326‐101CH2S‐P
CLOSE
CLOSE
480133 2"‐CLD‐011098311‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011098314‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011098314‐101CH2S‐P
CLOSE
CLOSE
480134 2"‐CLD‐011098304‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011098305‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011098316‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011098321‐101CH2S‐P
CLOSE
CLOSE
480135 2"‐CLD‐011098310‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011098313‐101CH2S‐P
CLOSE
CLOSE
480136 2"‐CLD‐011098320‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011098325‐103CS1P‐N
CLOSE
CLOSE
480137 2"‐CLD‐011099301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011099303‐101CH2S‐P
CLOSE
CLOSE
480138 2"‐CLD‐011099302‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011099304‐101CH2S‐P
CLOSE
CLOSE
480140 2"‐CLD‐011098308‐101CH2S‐P
CLOSE
CLOSE
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 26 of 27
UNIT 011 – CDU/VDU
2"‐CLD‐011098309‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011098312‐101CH2S‐N
CLOSE
CLOSE
480141 2"‐CLD‐011013307‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011013308‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011013309‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011013310‐101CH2S‐P
CLOSE
CLOSE
480216 2"‐CLD‐011078340‐101CH2S‐N
CLOSE
CLOSE
480219 2"‐CLD‐011076301‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011076302‐101CS2P‐P
CLOSE
CLOSE
2"‐CLD‐011076303‐101CS2P‐P
CLOSE
CLOSE
480225 2"‐CLD‐011077301‐101CH2S‐P
CLOSE
CLOSE
480226 2"‐CLD‐011078328‐101CH2S‐N
CLOSE
CLOSE
2"‐CLD‐011078329‐101CH2S‐N
CLOSE
CLOSE
2"‐CLD‐011078336‐101CH2S‐P
CLOSE
CLOSE
480227 2"‐CLD‐011078330‐101CH2S‐N
CLOSE
CLOSE
2"‐CLD‐011078337‐101CH2S‐N
CLOSE
CLOSE
480228 2"‐CLD‐011078327‐101CH2S‐N
CLOSE
CLOSE
480229 2"‐CLD‐011078338‐101CH2S‐N
CLOSE
CLOSE
2"‐CLD‐011078339‐101CH2S‐N
CLOSE
CLOSE
2"‐CLD‐011078341‐101CH2S‐N
CLOSE
CLOSE
480230 2"‐CLD‐011078342‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011078343‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011078344‐101CH2S‐P
CLOSE
CLOSE
INTERMEDIATE PROCEDURE FOR
CLOSED DRAIN SHUTDOWN/DEGASSING/ GASSING/START‐UP
Procedure No. 011‐IP‐0017 Date: 17‐Aug‐2011 Rev. : 01 Pag. : 27 of 27
UNIT 011 – CDU/VDU
480231 2"‐CLD‐011078324‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011078345‐101CH2S‐P
CLOSE
CLOSE
2"‐CLD‐011078346‐101CH2S‐P
CLOSE
CLOSE
480232 2"‐LPS‐011078301‐101CS1P‐H
OPEN
CLOSE
2"‐LPS‐011078302‐101CS1P‐H
OPEN
CLOSE
6"‐LPF‐011078301‐101CH2F‐N
OPEN
CLOSE
2"‐CLD‐011078334‐101CH2S‐P
CLOSE
CLOSE
6” VENT VALVE D‐0014
CLOSE
OPEN
4"‐SLP‐011078001‐103CH2S‐P
OPEN
CLOSE
6"‐CLD‐011078301‐101CH2S‐N
OPEN
CLOSE
24” MAN HOLE M2
CLOSE
OPEN
24” MAN HOLE K1
CLOSE
OPEN
24” MAN HOLE K2
CLOSE
OPEN
24” MAN HOLE M1
CLOSE
OPEN
480289 2"‐CLD‐011230301‐101CH2S‐N
OPEN
CLOSE
480290 2"‐CLD‐011230302‐101CH2S‐N
OPEN
CLOSE
P&ID´S : SA‐JER‐DS011‐TRJR‐480216/230/231/232
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 39.
E-0016/17/18 GASSING/ START-UP/ SHUTDOWN/ DEGASSING Document Number
Description
SA-JER-DS011-TRJR-400009
E-0016/17/18 GASSING/START-UP/SHUTDOWN/DEGASSING
Rev. 01
INTERMEDIATE PROCEDURE FOR
Procedure No. 011‐IP‐0018
E‐0016/17/18 SHUTDOWN/ P.O Date: 06‐OCT‐2011 DEGASSING/GASSING/START‐UP Rev. : 01 Pag. : 1 of 19
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
ORIGINAL SIGNED IN PROJECT FILE
DOCUMENT: SA‐JER‐DS011‐TRJR‐400009
INTERMEDIATE PROCEDURE FOR
E‐0016/17/18 SHUTDOWN/ DEGASSING/GASSING/START‐UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Note: This document does not replace the corresponding “Operating Procedure” or “OPERGUID” which will be developed by SATORP. REVISION CONTROL REV. 00 01
DATE 12‐MAY‐2011 06‐OCT‐2011
DESCRIPTION ISSUE FOR REVIEW APPROVED FOR CONSTRUCTION
PREPARED BY
CHECKED BY
APPROVED BY
Miguel A. Castro
José Luis Roldan
Juan Lechuga
DISCIPLINE CODE PRO Document Class: 2
DOCUMENT TYPE MAN
UNIT 011
SYSTEM
Legend
o ◊
Action Verification Safety Action
B – Board Operator F – Field Operator S – Shift Supervisor
INTERMEDIATE PROCEDURE FOR
E‐0016/17/18 SHUTDOWN/ DEGASSING/GASSING/START‐UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0018 Date: 06‐OCT‐2011 Rev. : 01 Pag. : 2 of 19
LEVEL I LOGIC DIAGRAM INITIAL STATE Heat exchangers E‐0016A/E‐0017A/ E‐0018 A/B in normal operation
100 SHUTDOWN STABLE STATE S1 Heat exchangers E‐0016A/E‐0017A/ E‐0018 A/B out of service, but not purged and degassing 200 DRAINING AND DEGASSING STABLE STATE S2 (Note 1) Heat exchangers E‐0016A/E‐0017A/ E‐0018 A/B to/from Maintenance 300 GASSING
STABLE STATE S3 Process Blinds have been checked and Heat exchangers purged/degassing
400 START UP STABLE STATE S4 Heat exchangers E‐0016A/E‐0017A/ E‐0018 A/B in normal operation after Maintenance
500 FINAL CHECK LIST FINAL STATE Heat exchangers E‐0016A/E‐0017A/ E‐0018 A/B in normal operation after Maintenance Note 1: This stable state actually includes two different states: the state when Heat exchangers E‐0016A/E‐0017A/E‐0018 A/B have been purged and degassing and are available for Maintenance, and the state when the heat exchanger are taken over from Maintenance (After Cleaning)
INTERMEDIATE PROCEDURE FOR
E‐0016/17/18 SHUTDOWN/ DEGASSING/GASSING/START‐UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0018 Date: 06‐OCT‐2011 Rev. : 01 Pag. : 3 of 19
LEVEL I SUMMARY LOGIC DIAGRAM ....................................................................................................................................... 2 SUMMARY ................................................................................................................................................ 3 INITIAL STATE SHEET ................................................................................................................................. 4 100 SHUTDOWN ............................................................................................................................. 5 STABLE STATE 1 SHEET .............................................................................................................................. 7 200 DRAINING AND DEGASSING ..................................................................................................... 8 210 Draining ............................................................................................................................... 8 220 Degassing ............................................................................................................................ 8 STABLE STATE 2 SHEET ............................................................................................................................ 10 300 GASSING ................................................................................................................................ 11 310 Process Blind ..................................................................................................................... 11 320 Gassing .............................................................................................................................. 11 STABLE STATE 3 SHEET ............................................................................................................................ 12 400 START UP PROCEDURE ........................................................................................................... 13 STABLE STATE 4 SHEET ............................................................................................................................ 14 500 FINAL CHECK LIST ................................................................................................................... 15 FINAL STATE SHEET ................................................................................................................................. 16
INTERMEDIATE PROCEDURE FOR
E‐0016/17/18 SHUTDOWN/ DEGASSING/GASSING/START‐UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0018 Date: 06‐OCT‐2011 Rev. : 01 Pag. : 4 of 19
LEVEL III INITIAL STATE SHEET INITIAL STATE Heat exchangers E‐0016A/E‐0017A/ E‐0018 A/B in normal operation DESCRIPTION o Heat exchangers E‐0016A/E‐0017A/E‐0018A/B are in operation. o Closed drain with blind. o Flushing oil with blind. o Steam injection close and flexible connection disassembled. o All purges are closed. UTILITIES o All utility services (plant air, instrument air, cooling water, service water, nitrogen, fuel gas, LP steam) are available at the unit Battery Limit. o Steam tracing are in service. SAFETY ◊ Scaffolding shall be prepared to access to the heat exchangers. ◊ Extinguishers are in position and available. ◊ Monitor hoses are available. ◊ Safety showers are available. ◊ Personal warning system are provide (like hydrogen sulphide detectors)
INTERMEDIATE PROCEDURE FOR
E‐0016/17/18 SHUTDOWN/ DEGASSING/GASSING/START‐UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0018 Date: 06‐OCT‐2011 Rev. : 01 Pag. : 5 of 19
LEVEL III ACTIONS 100
SHUTDOWN
o
(F) Connect the steam flexible hose connection on UC valves topped crude side. (F) Connect the steam flexible hose connection on UC valves HVGO pumparound side. (F) Connect the steam flexible hose connection on UC valves HAGO pumparound side. (F) Connect the steam flexible hose connection on UC valves Vacuum residue side. (F) Swing to open position isolation blind on all closed drain for all process line involves. (F) Swing to open position isolating blind on flushing oil connection on topped crude outlet line E‐0018A. (F) Swing to open position isolating blind on flushing oil connection on HVGO inlet E‐0016A. (F) Swing to open position isolating blind on flushing oil connection on HAGO inlet E‐0017A. (F) Swing to open position isolating blind on flushing oil connection on Vacuum residue inlet E‐ 0018A. (B) Reduce feed flowrate at the 60% of the normal throughput adjusted the set point of flow controller 011‐FC‐0006 or maximize the flow rate through the E‐0016B/E‐0017B/E‐0018C/D in normal operation. (B) Reduce the set point of the following flow controller to 60% of their normal flow rate: ‐ Kerosene product to BL 011‐FC0139 ‐ LAGO product to BL 011‐FC0140 ‐ HAGO product to BL 011‐FC0120 ‐ Reflux to 011‐C0002 011‐FC0019 ‐ Kerosene PA 011‐FC0003 ‐ LAGO PA 011‐FC0023 ‐ HAGO PA 011‐FC0013 ‐ LVGO internal reflux 011‐FC0046 ‐ HVGO PA 011‐FC0012 ‐ Wash Oil 011‐FC0051 (F) Close the inlet block valves of HVGO PA to E‐0016A. (B) Monitor the HVGO PA temperature using the TI‐0196. (F) Close the inlet block valves of topped crude to E‐0016A. (B) Monitor the cooling temperature on topped crude side through TI‐0293. (F) Monitor the cooling temperature on HVGO PA side through TI‐0064. (F) Close the outlet block valves of HVGO PA from E‐0016A, only when temperature on topped crude side is below of 200 ºC and temperature on HVGO PA side is below of 252ºC. (F) Close the inlet block valves of HAGO PA to E‐0017A. (F) Monitor the HAGO PA temperature using the TI‐0071. (F) Close the outlet block valves of HAGO PA from E‐0016A, only when temperature on temperature on HVGO PA side is below of 262 ºC. (F) Close the inlet block valves of Vacuum residue to E‐0018A. (F) Monitor the vacuum residue temperature using the TI‐0073, TW‐0296. (F) Close the outlet block valves of Vacuum residue from E‐0018A, only when temperature on temperature on Vacuum residue side is below of 276 ºC. (F) Monitor the cooling temperature on topped crude side through TI‐0072, TI‐0294, and TW‐ 0296.
INTERMEDIATE PROCEDURE FOR
E‐0016/17/18 SHUTDOWN/ DEGASSING/GASSING/START‐UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0018 Date: 06‐OCT‐2011 Rev. : 01 Pag. : 6 of 19
(F) Close the outlet block valves of topped crude from E‐0018A, only when temperature on topped crude side is below of 245 ºC. (F) Stop the steam tracing on HVGO PA, HAGO PA and Vacuum residue monitories sides. After certain time the temperatures for all products inside of this circuit will tend to decrease and when all temperature are around of 200 ºC shall be proceed to purge and degassing
STABLE STATE S1 Heat exchangers E‐0016A/E‐0017A/ E‐0018 A/B out of service, but not purged and degassed
INTERMEDIATE PROCEDURE FOR
E‐0016/17/18 SHUTDOWN/ DEGASSING/GASSING/START‐UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0018 Date: 06‐OCT‐2011 Rev. : 01 Pag. : 7 of 19
LEVEL III STABLE STATE 1 SHEET STABLE STATE S1 Heat exchangers E‐0016A/E‐0017A/ E‐0018 A/B out of service, but not purged and degassed DESCRIPTION o Heat exchangers E‐0016A/E‐0017A/E‐0018A/B are out of service, but no purged and degassed. o Heat exchangers have been blocked in both sides (side tubes and shell). o Closed drain is with blind in open position. o Flushing oil with blind in open position. o Steam injection close and flexible connection available. o All purges are closed. UTILITIES o All utility services (plant air, instrument air, cooling water, service water, nitrogen, fuel gas, LP steam) are available at the unit Battery Limit. o Steam tracing are out of service. SAFETY ◊ Closed drain drum D‐0014 shall be prepared to receive hydrocarbon from heat exchangers. ◊ Scaffolding shall be prepared to access: purge on the shell and tube sides for heat exchangers, move insulating materials, move blinds. ◊ Extinguishers are in position and available. ◊ Fire monitors are available. ◊ Safety showers are available. ◊ Personal warning system are provide (like hydrogen sulphide detectors)
INTERMEDIATE PROCEDURE FOR
E‐0016/17/18 SHUTDOWN/ DEGASSING/GASSING/START‐UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0018 Date: 06‐OCT‐2011 Rev. : 01 Pag. : 8 of 19
LEVEL III ACTIONS 200
DRAINING AND DEGASSING
210 Draining (F) For topped crude side, open drains low point to the closed drains system located at inlet E‐ 0016‐A, inlet E‐0017‐A and inlet E‐0018‐B to drainage and empty the hydrocarbon inside heat exchangers and lines. o (F) Check an increase of temperature in TI‐0262 in closed drain, meaning the drain lines is not obstructed. (F) Open the valve of flushing oil to E‐0018‐A outlet topped crude. (F) Control the dilution on topped crude side with purge and pressure gauge. (F) For HVGO PA side, open drain low point to the closed drains system located at E‐0016‐A outlet line to drainage and empty the hydrocarbon inside heat exchanger and lines. (F) Open the valve of flushing oil to E‐0016‐A inlet HVGO PA. (F) Control the dilution HVGO PA side with purge and pressure gauge. (F) For HAGO PA side, open drain low point to the closed drains system located at E‐0017‐A outlet line to drainage and empty the hydrocarbon inside heat exchanger and lines. (F) Open the valve of flushing oil to E‐0017‐A inlet HAGO PA. (F) Control the dilution HAGO PA side with purge and pressure gauge. (F) For Vacuum residue side, open drain low point to the closed drain system located at E‐0018‐ B outlet line to drainage and empty the hydrocarbon inside heat exchanger and lines. (F) Open the valve of flushing oil to E‐0018‐A inlet Vacuum residue (F) Control the dilution Vacuum residue side with purge and pressure gauge. 220 Degassing (F) Close the valve of flushing oil to E‐0018‐A topped crude outlet. (F) Close the valve of flushing oil to E‐0016‐A inlet HVGO PA. (F) Close the valve of flushing oil to E‐0017‐A inlet HAGO PA. (F) Close the valve of flushing oil to E‐0018‐A inlet Vacuum residue. (F) Swing to close position isolating blind on flushing oil connection on topped crude outlet line E‐0018A. (F) Swing to close position isolating blind on flushing oil connection on HVGO inlet E‐0016‐A. (F) Swing to close position isolating blind on flushing oil connection on HAGO inlet E‐0017‐A. (F) Swing to close position isolating blind on flushing oil connection on Vacuum residue inlet E‐ 0018A. (F) Open steam the UC valve to the E‐0016‐A topped crude inlet lines. (F) Open the UC valve to E‐0016‐A HVGO PA outlet line. (F) Open the UC valve to E‐0017‐A HAGO PA outlet line. (F) Open the UC valve to E‐0018‐A/B Vacuum residue outlet line. (F) Open all vents directly to atmosphere through heat exchangers top vents and lines high point vents. (F) Control the degassing on topped crude side is when no oil is observed. (F) Control the degassing on HVGO PA, HAGO PA and Vacuum residue is when no oil is observed.
INTERMEDIATE PROCEDURE FOR
E‐0016/17/18 SHUTDOWN/ DEGASSING/GASSING/START‐UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0018 Date: 06‐OCT‐2011 Rev. : 01 Pag. : 9 of 19
(F) Drain again any liquid from low point in the unit. (F) Stop steam out gradually. (F) Close steam the UC valve to the E‐0016A topped crude inlet lines. (F) Close the UC valve to E‐0016‐A HVGO PA outlet line. (F) Close the UC valve to E‐0017‐A HAGO PA outlet line. (F) Close the UC valve to E‐0018‐A/B Vacuum residue outlet line. (F) Close the drains low point to the closed drains system located at inlet E‐0016‐A, inlet E‐ 0017‐A and inlet E‐0018‐B. (F) For HVGO PA side, close drain low point to the closed drains system located at E‐0016‐A outlet line. (F) For HAGO PA side, close drain low point to the closed drains system located at E‐0017‐A outlet line. (F) For Vacuum residue side, close drain low point to the closed drain system located at E‐0018‐ B outlet line. (F) Swing to close position isolating blind on block valves heat exchanger E‐0016A topped crude inlet line. (F) Swing to close position isolating blind on block valves heat exchanger E‐0018A topped crude outlet line. (F) Swing to close position isolating blind on block valves heat exchanger E‐0016A HVGO PA inlet line. (F) Swing to close position isolating blind on block valves heat exchanger E‐0016A HVGO PA outlet line. (F) Swing to close position isolating blind on block valves heat exchanger E‐0017A HAGO PA inlet line. (F) Swing to close position isolating blind on block valves heat exchanger E‐0017A HAGO PA outlet line. (F) Swing to close position isolating blind on block valves heat exchanger E‐0018A Vacuum residue inlet line. (F) Swing to close position isolating blind on block valves heat exchanger E‐0018B Vacuum residue outlet line. (F) Purging, flush out and drain vacuum residue side to ensure the absence of fluids in this equipment. Immediately, proceed to blind this circuit.
STABLE STATE S2 Heat exchangers E‐0016A/E‐0017A/ E‐0018 A/B have been purged and degassed available to Maintenance
INTERMEDIATE PROCEDURE FOR
E‐0016/17/18 SHUTDOWN/ DEGASSING/GASSING/START‐UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0018 Date: 06‐OCT‐2011 Rev. : 01 Pag. : 10 of 19
LEVEL III STABLE STATE 2 SHEET STABLE STATE S2 (NOTE 1) Heat exchangers E‐0016A/E‐0017A/ E‐0018 A/B to/from Maintenance DESCRIPTION o Heat exchangers E‐0016 A/ E‐0017 A/E‐0018 A/B are isolated and blinded as per marked P&ID (SA‐JER‐DS011‐TRJR‐480025/480026/480027) included in Level IV. o CDU/VDU Unit is still in operation with the crude flow rate adjusted according this operation. o Drainage services are ready for use, in closed position. o Steam tracing are closed on HVGO PA (E‐0016‐A), HAGO PA (E‐0017‐A) and VAC Residue (E‐ 0018‐A/B). o Flushing oil with blind. DESCRIPTION (if Heat Exchangers are to Maintenance) o Heat exchangers E‐0016 A/ E‐0017 A/E‐0018 A/B have been purged and degassed. o Closed all vents and drains. DESCRIPTION (If Heat Exchangers are taken over from Maintenance) o Heat exchangers E‐0016 A/ E‐0017 A/E‐0018 A/B are cleaned. o Tightness tests have been performed. UTILITIES o All utility services (plant air, instrument air, cooling water, service water, nitrogen, fuel gas, LP steam) are available at the unit Battery Limit. o Flexible steam hose connection UC valve are available and blind in open position. o Closed drain system are ready for used, in closed position SAFETY ◊ Closed drain drum D‐0014 shall be prepared to receive hydrocarbon from heat exchangers. ◊ Extinguishers are in position and available. ◊ Fire monitors are available. ◊ Safety showers are available. ◊ Personal warning system are provide (like hydrogen sulphide detectors) Note 1: This stable state actually includes two different states: the state when Heat exchangers E‐0016A/E‐0017A/E‐0018 A/B have been purged and degassed and are available for Maintenance and the state when the heat exchangers are taken over from Maintenance (After Cleaning)
INTERMEDIATE PROCEDURE FOR
E‐0016/17/18 SHUTDOWN/ DEGASSING/GASSING/START‐UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0018 Date: 06‐OCT‐2011 Rev. : 01 Pag. : 11 of 19
LEVEL III ACTIONS 300
GASSING
310 Process Blind (F) Move isolation blinds to open position at the topped crude inlet line to E‐0016A, and topped crude outlet line from E‐0018A, P&ID´s: 480025 and 480027. (F) Move isolation blinds to open position at heat exchanger E‐0016A HVGO PA inlet/outlet lines, P&ID: 480025. (F) Move isolation blinds to open position at heat exchanger E‐0017A HAGO PA inlet/outlet lines, P&ID: 480026. (F) Move isolation blinds to open position at heat exchanger E‐0018A/B Vacuum residue inlet/outlet lines, P&ID: 480027. (F) Move isolation blind to open position on all closed drain connection for all process line involves. 320 Gassing (F) Connect the flexible steam hose connection to UC valves into the topped crude circuit, located upstream E‐0016A, P&ID: 480025. (F) Connect the flexible steam hose connection to UC valves into E‐0016A HVGO PA outlet line, P&ID: 480025. (F) Connect the flexible steam hose connection to UC valves into E‐0017A HAGO PA outlet line, P&ID: 480026. (F) Connect the flexible steam hose connection to UC valves into E‐0018A/B Vacuum residue outlet line, P&ID: 480027. (F) Open LP steam to the topped crude heat exchangers E‐0016A/E‐0017A/E‐0018A/B and lines associated to this circuit. (F) Open the UC valve to E‐0016A HVGO PA outlet line. (F) Open the UC valve to E‐0017A HAGO PA outlet line. (F) Open the UC valve to E‐0018A/B Vacuum residue outlet line. (F) Open all vents directly to atmosphere through heat exchangers top vents and lines high point vents. (F) Drain any condensate as rapidly as it forms through drains on all equipment and all low points in the lines. (F) Proceed to stop the steam injection to all UC valves and later close all vents on E‐0016A topped crude inlet E‐0016A, E‐0016A HVGO PA outlet line, E‐0017A HAGO PA outlet line, E‐ 0018A/B Vacuum residue outlet line, when the system have been thoroughly purged and the oxygen have been removed from the system. (F) Close all drains when the unit is dry (no condensate comes out of the drains).
STABLE STATE S3 Process Blinds have been checked and Heat exchangers purged/ degassed
INTERMEDIATE PROCEDURE FOR
E‐0016/17/18 SHUTDOWN/ DEGASSING/GASSING/START‐UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0018 Date: 06‐OCT‐2011 Rev. : 01 Pag. : 12 of 19
LEVEL III STABLE STATE 3 SHEET STABLE STATE S3 Process Blinds have been checked and Heat exchangers gassed DESCRIPTION o Heat exchangers E‐0016A/E‐0017A/E‐0018A/B and associated process line have been purged/ degassed and ready to restart. o Closed drain system are ready for used, in closed position UTILITIES o All utility services (plant air, instrument air, cooling water, service water, nitrogen, fuel gas, LP steam) are available at the unit Battery Limit. SAFETY ◊ Closed drain drum D‐0014 shall be prepared to receive hydrocarbon from heat exchangers. ◊ Extinguishers are in position and available. ◊ Fire monitors are available. ◊ Safety showers are available. ◊ Personal warning system are provide (like hydrogen sulphide detectors)
INTERMEDIATE PROCEDURE FOR
E‐0016/17/18 SHUTDOWN/ DEGASSING/GASSING/START‐UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0018 Date: 06‐OCT‐2011 Rev. : 01 Pag. : 13 of 19
LEVEL III ACTIONS 400
START UP PROCEDURE
o o o o
(F) Open gradually block valves at heat exchanger E‐0016A inlet line to fill all circuit with topped crude (12”‐CRD‐011013002‐106CS1P), P&ID: 480025. (F) Open gradually block valve into closed drain to control the filling step of heat exchangers E‐ 0016A/E‐0017A/E‐0018A/B. (F) Open block valves at heat exchanger E‐0018A outlet line to line‐up the circuit to the topped crude (12”‐CRD‐011014003‐106CS2P), P&ID: 480025. (F) Verify and monitor the temperature during the filling through TI‐0293, TI‐0072. (F) In case to be required, a pressure gauge indicator can be temporally installed to check the fill‐up step. (F) Open gradually block valves at heat exchanger E‐0016A HVGO PA inlet line (12”‐HGO‐ 011015003‐103CL2P), P&ID: 480025. (F) Open block valves at heat exchanger E‐0016A HVGO PA outlet line (12”‐HGO‐011013003‐ 103CL2P), P&ID: 480025. (F) Verify and monitor the HVGO PA temperature through TI‐0064. (F) Open gradually block valves at heat exchanger E‐0016A HAGO PA inlet line (10”‐HGO‐ 011022002‐103CL2P), P&ID: 480026. (F) Open block valves at heat exchanger E‐0016A HAGO PA outlet line (10”‐HGO‐011024002‐ 103CL2P), P&ID: 480026. (F) Verify and monitor the HAGO PA temperature through TI‐0071. (F) Open gradually block valves at heat exchanger E‐0018A Vacuum residue inlet line (10”‐RES‐ 011015003‐103CL4P), P&ID: 480027. (F) Open block valves at heat exchanger E‐0018A Vacuum residue outlet line (10”‐RES‐ 011014002‐103CL2P), P&ID: 480027. (F) Verify and monitor the Vacuum residue temperature through TI‐0073. (BOP) Adjust the set point of flow controller 011‐FC0006 at pre flash column inlet to the increase the feed flow rate to the unit up to normal operation. (B) Monitor the topped crude temperature going to the E‐0019´s. (F) Move isolation blind to closed position on all closed drain connection for all process line involves. P&ID: 480025, 480026 and 480027. (F) Disconnected the steam flexible connection on all UC valves topped crude, HVGO PA, HAGO PA and Vacuum residue side. (F) Put in service the steam tracing on HVGO PA, HAGO PA and Vacuum residue sides.
STABLE STATE S4 Heat exchangers E‐0016A/E‐0017A/ E‐0018 A/B in normal operation after Maintenance
INTERMEDIATE PROCEDURE FOR
E‐0016/17/18 SHUTDOWN/ DEGASSING/GASSING/START‐UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0018 Date: 06‐OCT‐2011 Rev. : 01 Pag. : 14 of 19
LEVEL III STABLE STATE 4 SHEET STABLE STATE S4 Heat exchangers E‐0016A/E‐0017A/ E‐0018 A/B in normal operation after Maintenance DESCRIPTION o Heat exchangers E‐0016A/E‐0017A/E‐0018A/B in normal operation after maintenance. o Closed drain is with blind in closed position. o Flushing oil with blind in closed position. o Steam injection close and flexible connection available. o All purges are closed. UTILITIES o All utility services (plant air, instrument air, cooling water, service water, nitrogen, fuel gas, LP steam) are available at the unit Battery Limit. o Steam tracing are in service. SAFETY ◊ Extinguishers are in position and available. ◊ Fire monitors are available. ◊ Safety showers are available. ◊ Personal warning system are provide (like hydrogen sulphide detectors)
INTERMEDIATE PROCEDURE FOR
E‐0016/17/18 SHUTDOWN/ DEGASSING/GASSING/START‐UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0018 Date: 06‐OCT‐2011 Rev. : 01 Pag. : 15 of 19
LEVEL III ACTIONS 500
FINAL CHECK LIST
o
Heat exchangers E‐0016A/E‐0017A/E‐0018A/B in service after maintenance.
FINAL STATE Heat exchangers E‐0016A/E‐0017A/ E‐0018 A/B in normal operation
INTERMEDIATE PROCEDURE FOR
E‐0016/17/18 SHUTDOWN/ DEGASSING/GASSING/START‐UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0018 Date: 06‐OCT‐2011 Rev. : 01 Pag. : 16 of 19
LEVEL III FINAL STATE SHEET FINAL STATE Heat exchangers E‐0016A/E‐0017A/ E‐0018 A/B in normal operation DESCRIPTION o Heat exchangers E‐0016A/E‐0017A/E‐0018A/B are in operation. o Closed drain with blind. o Flushing oil with blind. o All purges are closed.
INTERMEDIATE PROCEDURE FOR
E‐0016/17/18 SHUTDOWN/ DEGASSING/GASSING/START‐UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0018 Date: 06‐OCT‐2011 Rev. : 01 Pag. : 17 of 19
LEVEL IV Abbreviation CDU: Crude Distillation Unit VDU: Vacuum Distillation Unit LP: Low Pressure WWT: Waste Water Treatment HAGO: Heavy Atmospheric Crude MVGO: Medium Vacuum Crude HVGO: Heavy Vacuum Crude Vac. Residue: VACUUM RESIDUE PA: Pump around BL: Battery Limit UC: Utility connection
INTERMEDIATE PROCEDURE FOR
E‐0016/17/18 SHUTDOWN/ DEGASSING/GASSING/START‐UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
BLIND LIST
Procedure No. 011‐IP‐0018 Date: 06‐OCT‐2011 Rev. : 01 Pag. : 18 of 19
CDU/VDU UNIT (UNIT 011) BLIND LIST Line number
P&ID
Service
2"-CRD-011014003-106CS2P-P 2"-CRD-011013007-106CS1P-P 2"-CRD-011013005-106CS1P-P 12"-CRD-011013002-106CS1P-H 12"-CRD-011013002-106CS1P-H 2"-CRD-011013006-106CS1P-P 2"-HGO-011013008-103CL2P-S 12"-HGO-011013003-103CL2P-S 2"-HGO-011013022-103CL2P-P 12"-HGO-011013003-103CL2P-S 2"-HGO-011013007-103CL2P-S 12"-HGO-011015003-103CL2P-S 2"-HGO-011015003-103CL2P-P 12"-HGO-011015003-103CL2P-S 2"-CRD-011014006-106CS1P-P 10"-RES-011015003-103CL4P-S 2"-CRD-011014003-106CS2P-P 12"-CRD-011014003-106CS2P-H 12"-CRD-011014003-106CS2P-H 2"-HGO-011022002-103CL2P-P 10"-HGO-011022002-103CL2P-H 2"-HGO-011022002-103CL2P-P 10"-HGO-011022002-103CL2P-H 2"-HGO-011014005-103CL2P-P 10"-HGO-011014002-103CL2P-H 2"-CRD-011014005-106CS1P-P 2"-CRD-011014004-106CS1P-P 10"-HGO-011014002-103CL2P-H 2"-HGO-011014004-103CL2P-P 2"-HGO-011014008-103CL2P-P 2"-RES-011014009-103CL2P-S 2"-CRD-011014008-106CS1P-P 2"-RES-011014007-103CL2P-S 10"-RES-011014002-103CL2P-S 10"-RES-011014002-103CL2P-S 6"-RES-011014003-103CL2P-S 2"-RES-011014003-103CL2P-P 2"-RES-011014006-103CL4P-S 2"-RES-011014008-103CL2P-S 2"-HGO-011014003-103CL2P-P 2"-HGO-011014006-103CL2P-P 2"-HGO-011014009-103CL2P-P 2"-HGO-011013023-103CL2P-P 2"-HGO-011014010-103CL2P-P 2"-HGO-011015003-103CL2P-P 2"-CRD-011013008-106CS1P-P 2"-RES-011015003-103CL4P-P 2"-RES-011015003-103CL4P-P 10"-RES-011015003-103CL4P-S 2"-RES-011014010-103CL2P-P 2"-RES-011014011-103CL2P-P
DS011-TRJR-480027 DS011-TRJR-480025 DS011-TRJR-480025 DS011-TRJR-480025 DS011-TRJR-480025 DS011-TRJR-480025 DS011-TRJR-480025 DS011-TRJR-480025 DS011-TRJR-480025 DS011-TRJR-480025 DS011-TRJR-480025 DS011-TRJR-480025 DS011-TRJR-480025 DS011-TRJR-480025 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480026 DS011-TRJR-480026 DS011-TRJR-480026 DS011-TRJR-480026 DS011-TRJR-480026 DS011-TRJR-480026 DS011-TRJR-480026 DS011-TRJR-480026 DS011-TRJR-480026 DS011-TRJR-480026 DS011-TRJR-480026 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480026 DS011-TRJR-480026 DS011-TRJR-480026 DS011-TRJR-480025 DS011-TRJR-480026 DS011-TRJR-480025 DS011-TRJR-480025 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480027 DS011-TRJR-480027
CRUDE TOPPED CRUDE TOPPED CRUDE TOPPED CRUDE TOPPED CRUDE TOPPED CRUDE HVGO HVGO HVGO HVGO HVGO HVGO HEAVY GAS OIL HVGO TOPPED CRUDE VACUUM RESIDUE CRUDE TOPPED CRUDE TOPPED CRUDE HEAVY GAS OIL HAGO HEAVY GAS OIL HAGO HAGO HAGO TOPPED CRUDE TOPPED CRUDE HAGO HAGO HAGO VACUUM RESIDUE TOPPED CRUDE VACUUM RESIDUE VACUUM RESIDUE VACUUM RESIDUE VACUUM RESIDUE RESIDUE VACUUM RESIDUE VACUUM RESIDUE HAGO HAGO HAGO HVGO HC CLOSED DRAIN HEAVY GAS OIL TOPPED CRUDE RESIDUE RESIDUE VACUUM RESIDUE VACUUM RESIDUE VACUUM RESIDUE
INTERMEDIATE PROCEDURE FOR
E‐0016/17/18 SHUTDOWN/ DEGASSING/GASSING/START‐UP UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
MARKED PID’S
Procedure No. 011‐IP‐0018 Date: 06‐OCT‐2011 Rev. : 01 Pag. : 19 of 19
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 40.
VDU BYPASS Document Number
Description
SA-JER-DS011-TRJR-400010
VDU BYPASS
Rev. 01
ORIGINAL SIGNED IN PROJECT FILE
INTERMEDIATE PROCEDURE FOR
VACUUM UNIT BY PASS UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0022 Date: 08‐DEC‐2011 Rev. : 01 Pag. : 1 of 20
DOCUMENT: SA‐JER‐DS011‐TRJR‐400010
INTERMEDIATE PROCEDURE FOR
VACUUM UNIT BY PASS UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Note: This document does not replace the corresponding “Operating Procedure” or “OPERGUID” which will be developed by SATORP. REVISION CONTROL REV. 01 0
DATE 08‐DEC‐2011 02‐JUN‐2011
PREPARED BY Tulio Hernandez
DISCIPLINE CODE PRO Document Class: 2
DESCRIPTION APPROVED FOR CONSTRUCTION ISSUE FOR REVIEW
CHECKED BY
APPROVED BY Juan Lechuga
Miguel A. Castro DOCUMENT TYPE MAN
UNIT 011
SYSTEM
Legend
Action o Verification ◊ Safety Action
B – Board Operator F– Field Operator S – Shift Supervisor
INTERMEDIATE PROCEDURE FOR
VACUUM UNIT BY PASS UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0022 Date: 08‐DEC‐2011 Rev. : 01 Pag. : 2 of 20
LEVEL I LOGIC DIAGRAM
INITIAL STATE CDU/VDU at Normal Operation
100 REDUCTION OF THE CAPACITY OF THE UNIT TO TURNDOWN CAPACITY
STABLE STATE S1 CDU‐VDU Unit mini flow
200 VACUUM TOWER BY‐PASS STABLE STATE S2 Atmospheric Residue to Storage
300
011‐C‐0003 BOTTOMS FILL UP WITH FLUSHING OIL, DRAINING AND DEGASSING FINAL STATE VDU Bypassed
Note: The normal operation of the unit is described in the procedure “CDU/VDU Normal Operation”
INTERMEDIATE PROCEDURE FOR
VACUUM UNIT BY PASS UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0022 Date: 08‐DEC‐2011 Rev. : 01 Pag. : 3 of 20
LEVEL I SUMMARY LOGIC DIAGRAM ................................................................................................................................ 2 SUMMARY ......................................................................................................................................... 3 INITIAL STATE SHEET .......................................................................................................................... 4 100 REDUCTION OF THE CAPACITY OF THE UNIT TO TURNDOWN CAPACITY ............................ 5 STABLE STATE 1 SHEET ....................................................................................................................... 7 200 VACUUM TOWER BY‐PASS ................................................................................................ 8 STABLE STATE 2 SHEET ...................................................................................................................... 13 300 011‐C‐0003 BOTTOMS FILL UP WITH FLUSHING OIL, DRAINING AND DEGASSING ............. 14 310 Flushing Oil Procedure ..................................................................................................... 14 320 Draining Procedure.......................................................................................................... 14 330 Degassing Procedure ....................................................................................................... 15 FINAL STATE SHEET ........................................................................................................................... 16
INTERMEDIATE PROCEDURE FOR
VACUUM UNIT BY PASS UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0022 Date: 08‐DEC‐2011 Rev. : 01 Pag. : 4 of 20
LEVEL III INITIAL STATE SHEET INITIAL STATE CDU/VDU at Normal Operation DESCRIPTION o CDU/VDU Unit is in normal Operation. o VDU section is in Operation. o F‐0002 is in Operation. o Amine Section is in Operation. o Off gas is sent to Furnace. UTILITIES o Flushing Oil is Available. o Closed drain and Amine drain systems are empty and available. Note: Maximize the inventory of flushing oil in storage because there will be a high demand during the planned VDU unit shutdown for dilution or cooling. 200 m3 approx. of flushing oil will be required. SAFETY ◊ Storage shall be prepared to receive atmospheric residue. ◊ Downstream process units are notified about the planned shutdown of VDU unit and operation of CDU unit at 60%. ◊ Fire water system, safety showers, gas sensors are available. ◊ Monitors are available. ◊ Extinguishers are in position and ready to use. ◊ Personal protection equipment is available.
INTERMEDIATE PROCEDURE FOR
VACUUM UNIT BY PASS UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0022 Date: 08‐DEC‐2011 Rev. : 01 Pag. : 5 of 20
LEVEL III ACTIONS 100
REDUCTION OF THE CAPACITY OF THE UNIT TO TURNDOWN CAPACITY
(B) Notify all the process units (NHDT, LP HDS, HP HDS, DHC/MHC and DCU) and utilities about the planned VDU shutdown.
(B) Decrease the crude feed rate gradually by means of FC‐0006 to the maximum turndown capacity of the unit (60% of normal flow rate or 707.6 t/h). o (B) Once the feed is reduced check the throughput by FI‐0002.
(B) Reset the FC‐0015A‐H for each pass of Crude Heater F‐0001 by the level controller signal from LC‐0003 of the Preflash Column.
(B) Reduce the set point of the following flow controller to 60% of their normal flow rate: ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐
FC‐0062 for Naphtha Product FC‐0139 for Kerosene product FC‐0140 for LAGO product FC‐0120 for HAGO product FC‐0003 for KERO pump around FC‐0023 for LAGO pump around FC‐0013 for HAGO pump around FC‐0038 for LVGO pump around FC‐0012 for HVGO pump around FV‐0046 for LVGO reflux FC‐0051 for HVGO reflux (Wash oil)
Note: CDU/VDU board man shall communicate to NHDT board operator previous to reduce HAGO and LAGO pumparound. Any modification in the reboilers 111‐E‐0007 or 111‐E‐0009 has a major impact in CDU/VDU as reboilers duty is around 43% and 60%, for 111‐E‐0007 and 111‐E‐0009 respectively, of the total HAGO and LAGO pumparounds duty in that unit. Any adjustment in the temperature controller 111‐TC‐ 0109 or 111‐FC‐0028 set point shall be done smoothly and shall be communicated to CDU/VDU board.
(B) Reduce the stripping steam supply to 60% of their normal flow rate: ‐ Stripping steam to C‐0003 FC‐0056 ‐ Stripping steam to C‐0005 FC‐0027 ‐ Stripping steam to C‐0006 FC‐0028 Note: Stripping steam to C‐0001, FC‐0007 will be kept at its normal operating.
(B) Adjusted the wash water flow rate of desalters to 60% through FC‐0005 to (18.9 t/h) and FC‐0060 to (44.1 t/h). o (F) Verify the internal reflux of HVGO to the Wash section of the Vacuum column is higher than the minimum liquid wetting rate (minimum flow of 34 t/h).
INTERMEDIATE PROCEDURE FOR
VACUUM UNIT BY PASS UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0022 Date: 08‐DEC‐2011 Rev. : 01 Pag. : 6 of 20
o ◊ o
(F) Monitor the pressure on PT‐0067 (C‐0003 overhead) to avoid High Pressure due to vacuum stop and activation of 011‐ZC‐0321. (B) Avoid total Shutdown F‐0001 due to trip of F‐0002 by means of HS‐0021 (VDU by‐pass mode operation) ZC‐0335 and ZC‐0331. (F) Monitor the liquid level of the C‐0003 column bottom by LC‐0050 to avoid the activation of ZC‐0372.
STABLE STATE S1 CDU‐VDU Unit at minimum flow
INTERMEDIATE PROCEDURE FOR
VACUUM UNIT BY PASS UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0022 Date: 08‐DEC‐2011 Rev. : 01 Pag. : 7 of 20
LEVEL III STABLE STATE 1 SHEET STABLE STATE S1 CDU‐VDU Unit at minimum flow DESCRIPTION o CDU/VDU unit operating at minimum flow (707.6 t/h). o All products are on specification and going to downstream process units. UTILITIES o Flushing Oil is available. o Closed drain and Amine drain systems are empty and available. Note: Maximize the inventory of flushing oil in storage because there will be a high demand during the planned VDU unit shutdown for dilution or cooling. 200 m3 approx. of flushing oil will be required. SAFETY ◊ Storage shall be prepared to receive atmospheric residue. ◊ Downstream process units are notified about the planned shutdown of VDU unit and operation of CDU unit at 60%. ◊ Fire water system, safety showers, gas sensors are available. ◊ Monitors are available. ◊ Extinguishers are in position and ready to use. ◊ Personal protection equipment is available.
INTERMEDIATE PROCEDURE FOR
VACUUM UNIT BY PASS UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0022 Date: 08‐DEC‐2011 Rev. : 01 Pag. : 8 of 20
LEVEL III ACTIONS 200
VACUUM TOWER BY‐PASS
(S) Make turn to open position following blinds: ‐ 12” ‐RES‐011027005 on VDU by‐pass line (P&ID: 480066) ‐ 10”‐ RES‐011039004 on Short recirculation line (P&ID: 480066) ‐ 12” ‐RES‐011040020 on Atm. Residue to E‐0030A/B (P&ID: 480104&480100) ‐ 12”‐HGO‐011038023 on Atm. Residue from E‐0030A/B (P&ID: 480104&480100) ‐ 10”‐RES‐011099004 on Atm. Residue to fuel oil blending (P&ID: 480138&480100) ‐ 4”‐RES‐011039009 on Vacuum residue line to LV‐0050 (P&ID: 480103)
(B) Reduce as much as possible the liquid inventories in the Vacuum Tower bottom and in the chimney trays of LVGO, MVGO and HVGO the column by reducing the following set points : ‐ LC0044 (LVGO) ‐ LC0046 (MVGO) ‐ LC0048 (HVGO) ‐ LC0050 (bottom): final set point around 18% of LC range.
(F) Open 10% the following valves in order to align and warm the lines : ‐ 12” two block valves (valves‐1A) on line 12” RES‐011027005‐103CL4P‐S, (P&ID: 480066). For reference see figure 1 VDU By‐pass sketch included in Level IV. ‐ Check that 12” two block valves (valves‐1B) on line 12” RES‐011027005‐103CL4P‐S, which connected with vacuum residue line, is closed (P&ID: 480103). For reference see figure 1 VDU By‐pass sketch included in Level IV. ‐ 10” two block valves in the short recirculation line (valves‐3A) line 10” RES‐ 011039004‐103CL4P‐S, (P&ID: 480103). For reference, see figure 1 VDU By‐pass sketch included in Level IV. ‐ Open 10% the control valve HV‐0020 (Vacuum residue short recirculation). Line 10” RES‐011039004‐103CL4P‐S, (P&ID: 480066). For reference, see figure 1 VDU By‐pass Sketch included in Level IV. ‐ Check that 10” two block valves (valves‐3B) on short recirculation line which connected with atmospheric residue line is closed (P&ID: 480066). For reference, see figure 1 VDU By‐pass Sketch included in Level IV.
(B) Proceed to align the Off‐gas column C‐0007 to the flare system by pressing HIXS‐0041. This action initiates the interlock ZC‐0336 which change the position of the following valves: ‐ ZV‐0029 on Vent gas to Flare line, open ‐ ZV‐0030 on Off‐gas to Heater line, closed Note: Field operator closely communicates with the Board operator during these activities previous to VDU bypassed and avoids upset in the VDU column. Note: interlock ZC0336 is available with the same actions. This interlock is activated by low temperature in the firebox.
INTERMEDIATE PROCEDURE FOR
VACUUM UNIT BY PASS UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0022 Date: 08‐DEC‐2011 Rev. : 01 Pag. : 9 of 20
(B) Check the flow rate through F‐0002 passes to prevent the action of interlock ZC‐0334 which activated by FT‐0034 (A to H depending on pass).
(F) Line‐up the LVGO and VGO to Slops through Slop header : ‐ LVGO to slop (line: 6” LGO‐011037006‐103CS1P‐N, (P&ID: 480138) ‐ MVGO +HVGO to slop header inlet to E‐0037 A/D (line: 8” HGO‐011099003‐103CS1P‐S, and 16”‐SLP‐01199001‐103CS1P‐S, (P&ID: 480138). ◊ (B) Verify the temperature of the LVGO + HVGO is around 50 ºC by means of TT‐0050. Note: If temperature is higher than 50 ºC, cool down adding flushing oil through line 6”‐FLO‐011099301. o
(B/F) Block in the product flows to the downstream units and storage.
(B) Start reducing the outlet temperature of heater F‐0002 from normal operating temperature to below 360 ºC at a rate of 50 ºC/h by adjusting the TC‐0140 AA/TC‐0140 BA.
(B/F) During the reduction of the outlet temperature, some of the burners in the heater may need to be turned off to ensure a satisfactory flame/Fuel gas pressure in the other burners. Finally, shutdown of the burners wills occurs by closing the fuel gas valves. It is necessary make partial shutdown of F‐0002 and vented LP superheated steam to atmosphere through Y‐0009, while the temperature decreasing to 300 ºC.
(B) Reduce slowly and then stop C‐0003 stripping steam flow by adjusting FC‐0056 when the steam temperature downstream FV‐0056 (TT‐0180) is below to 250 ºC. Open LP superheated steam to the silencer to atmosphere at safe location Y‐0009.
(B) Close the ZV‐0021 by hand switch. This action initiates the interlock ZC‐0372 which opens ZV‐0019 to vent steam to the ATM.
(B) Increase the vacuum column flash zone pressure slowly by adjusting PC‐0072. This causes the ejector recycle valve PV‐0072 opens.
(B) Monitor the pressure on PT‐0067 (C‐0003 overhead) to avoid High Pressure due to vacuum stop and activation of ZC‐0321. o (B) Reduce slowly and then stop the motive steam to ejectors by adjusting PC‐0381. Note: Before to close MP steam to ejector, check all trays liquid levels. It is necessary stop the pump around and refluxes when you lose the discharge pressure on the G‐0015´s, G‐0016´s and G‐0017´s pumps. o
(B) Verify off‐gas pressure and flow rate at vacuum package discharge by means of PT‐0083 and FT‐0045, respectively. (F) Shut down the compressor K‐0001 from local panel when the ejectors become unstable or suction pressure falls below 0.07barg. When the compressor is stopped the interlock ZC‐0390 is activated which changes automatically the position of the following valves: ‐ ZV‐0082 on Off‐gas bypass line, open ‐ PV‐0308 on compressor recycle line, forced to full open ‐ ZV‐0018 on compressor suction line, closed ‐ ZV‐0027 on vent gas to C‐0007 line, closed ‐ ZV‐0028 on the compressor depressurizing line, open ‐ ZV‐0029 on vent gas to Flare line, open (already open by previous action) ‐ ZV‐0030 on Off‐gas to Heater F‐0002 line, closed (already closed by previous action)
Note: The interlock ZC‐0390 initiates the shutdown of the compressor in case of low‐low pressure at compressor suction by the PT‐0550.
INTERMEDIATE PROCEDURE FOR
VACUUM UNIT BY PASS UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0022 Date: 08‐DEC‐2011 Rev. : 01 Pag. : 10 of 20
Note: Please refer to the step 100 for intermediate procedure 011‐IP‐0010 Compressor 011‐K‐0001 Shutdown/Degassing/Gassing/Start‐up.
(F) Close the compressor package inlet and outlet valves. Note: On shutdown, the compressor package shall be purged with nitrogen to prevent condensate formation by cooling down of the casing and pipes. o
(B) When MVGO, HVGO and LVGO production ceases, Verify that the level controller of draw‐ off trays close the control valves (now routed to slop header): ‐ LVGO product (LC‐0044 / FC‐0144) ‐ MVGO product (LC‐0046 / FC‐0148) ‐ HVGO product (LC0048 / FC0149)
Note: LVGO and HVGO pump around circulation should continue as far as possible. The product condensed by the pump around is recycled to the vacuum column as reflux to the MVGO fractionation and overflash wash beds below, respectively. (B) Shut down the LVGO and HVGO pumparound flow level controllers allowing the LVGO, MVGO and HVGO trays overflow in the capacity of the hot reflux line is insufficient. o (B) Verify that the level in draw off trays is at minimum, to continue with the next step, stop the product pumps.
(B) Activate the following logic systems to stop the product pumps: ‐ ZC‐0355: LVGO product (G‐0015A/B). ‐ ZC‐0356: MVGO product (G‐0016A/B). ‐ UC‐0304: HVGO product (G‐0017A/B). Note: If the pumps G‐0017 are still operated when the level in draw off trays is lower than the low level, the following interlocks will be activated: ‐ ZC‐0357: stop HVGO product pump (G‐0017A/B)
(F) Isolate the circuits from VDU column and from BL (slop).
(F) Once the LVGO and HVGO pumps have been stopped, proceed to open the by‐pass lines of heat exchangers: ‐ E‐0005 (Fresh Crude/LVGO exchanger) ‐ E‐0010A/B (Desalted Crude/HVGO exchanger) ‐ E‐0015A/B (Topped Crude/HVGO exchanger), ‐ E‐0016A/B (Topped Crude/HVGO PA exchanger) ‐ E‐0019A‐C/D‐F (Topped Crude/HVGO PA exchanger).
(F) Start with the flushing oil and draining activities of the MVGO and HVGO circuits: o Make turn to open position all isolating blind on flushing oil connections. o Make turn to open position isolating blind on all closed drain for all process lines involves. o Open 2” two block valves on the flushing oil connections 2”‐FLO‐011038302 and 2”‐ FLO‐011038303 located on inlet line MVGO pumps G‐0016 A and B and align gasoil from flushing washing oil in case it is required. o Open 2” two block valves on the flushing oil connection locate on inlet line HVGO pumps G‐0017 A and B and align gasoil from washing oil. o
INTERMEDIATE PROCEDURE FOR
VACUUM UNIT BY PASS UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0022 Date: 08‐DEC‐2011 Rev. : 01 Pag. : 11 of 20
Open 4” two block valves on the flushing oil connections 4”‐FLO‐011013308 located downstream HVGO pump around filter S‐0001 and align gasoil from flushing oil. o Open 2” block valves on the flushing oil connections 2”‐FLO‐011039304 located downstream of HVGO internal reflux filter S‐0002 and align gasoil from flushing oil. o Open the following 2” flushing oil gasoil injection on HVGO circuits in case it is required: ‐Downstream line E‐0019A/D: 2”‐FLO‐011013302 and 2”‐FLO‐011015304. ‐Downstream line E‐0016A/B: 2”‐FLO‐011013302 and 2”‐FLO‐011013303. ‐Downstream line E‐0010A: 2”‐FLO‐011008304. ‐Upstream line to E‐0030A/B: 2”‐FLO‐011038304. ‐Downstream line to E‐0030A/B: 2”‐FLO‐011038305. (F) Start draining activities for the LVGO circuits includes G‐0015A/B, E‐0005, A‐0005A/H, E‐ 0029, ending in the battery limit. (F) Open the by‐pass lines of E‐0030 A/B to flush the HVGO circuit to BL (8”‐HGO‐011038021). (F) Isolate HVGO cooler E‐0030 A/B by closing inlet manual block valves (valves‐9A in figure 1) located on line 8”‐HGO‐011008001‐103CS1P‐S (Inlet HVGO line to E‐0030A/B). (F) Verify the temperature on the HVGO side decreasing by TW‐0032, TT‐0173. (B) Put temperature control station TC‐0173 in manual and close the TV‐0173, only when the HVGO temperature have start to decreasing up to 70 ºC approx. (F) Close the outlet block valve of HVGO from 011‐E‐0030B (valve‐9B in figure 1). (F) Immediately proceed to open the closed drain to flush and degassing the HVGO inlet/outlet lines and heat exchangers E‐0030 A/B. (F/B/S) Check the circuits MVGO, HVGO and LVGO unit has been flushed with FLO, drained to CLD. (F) Keep the Tempered water system in circulation. (B) Verify that outlet temperature of the F‐0002 heater is lower than 360 ºC, to continue with the next step. (F) Stop F‐0002 burners and close dilution steam supply to the passes of the heater. (F) Open 100% the 12” bypass valves (valves‐1A and valves‐1B in figure 1, line: 12” RES‐ 011027005‐103CL4P‐S, P&ID: 480066&480103) in order to line up the discharge line of the Atmospheric Residue Pump (G0014‐A/B) with the discharge line of the Vacuum Residue Pump (G‐0018A/B). o
o o o
Note: Since discharge pressure of G0018 is higher than discharge pressure of G0014‐A/B flow of Atmospheric Residue through this bypass line will not occur.
(F) Close and isolate the Vacuum Tower bottom quench circuit (line: 6”‐RES‐011014003‐ 103CL2P‐S, P&ID: 480027). See valve‐6 in figure 1.
(F) Open 100% the 10” valves (valves‐3B) in the short recirculation line (10”‐RES‐01139004‐ 103CL2P‐S, P&ID: 480103).
(F) Open 100 % the 10” valves (valves‐3A and valves‐3B) in the short recirculation line (10”‐ RES‐01139004‐103CL2P‐S, P&ID: 480100&480066).
(F) Open gradually the HV‐0020 in the short recirculation line (10”‐RES01139004‐103CL2P‐S, P&ID: 480066) and at the same time start to close the valves at vacuum residue pump discharge (valves‐4 in figure 1, line: 12”‐RES‐011039003‐103CL4P‐S, PID: 480103). At this step the atmospheric residue will flow through vacuum residue circuit and the vacuum residue pump is recirculation the oil back to the vacuum tower through the vacuum heater F‐0002, transfer line using the short recirculation line.
(F) Once the valves‐4 are closed, then proceed to close the inlet valves to heater (valves‐2 in figure 1, line; 12”‐RES011027003‐103CL4P‐S, P&ID: 480066).
INTERMEDIATE PROCEDURE FOR
VACUUM UNIT BY PASS UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0022 Date: 08‐DEC‐2011 Rev. : 01 Pag. : 12 of 20
Note: During the vacuum residue switch over by the atmospheric residue the CDU/VDU board man will adjust the bottom liquid level control on C‐0002/C‐0003. If it is necessary put the FC‐0052&0053 in manual mode
(B) Change Atmospheric column level control to mode VDU‐bypass by means of HS‐0005. This hand switch is foreseen to divert the LC0020 signal to the FC‐0052 & FC‐0053.
(B) Change Preflash column inlet temperature control (TC‐0057) to manual mode and order the control valve TV‐0057 to close. This way, E‐0018 bypass on the atmospheric residue side will be closed in order to maximize heat recovery from this stream and ensure sufficient atmospheric residue cooling.
(F) Line up the heat exchanger E‐0030 A/B for the cooling of Atmospheric Residue to Fuel oil blending via HAGO+LVGO storage. ‐ Open the 12” block manual valves (valves‐7A and 7B) in line Atm. Residue to E‐ 0030A/B (P&ID: 480104&480100). For reference, see figure 1 VDU By‐pass sketch. ‐ Close the 12” block manual valves (valve‐10) in line Vac. Residue to FV‐0053 (P&ID: 480104). For reference, see figure 1 VDU By‐pass sketch. ‐ Open the 12” block manual valves (valves‐8A and 8B) in line Atm. Residue from E‐ 0030 A/B (P&ID: 480104&480100). For reference, see figure 1 VDU By‐pass sketch. ‐ Open the 10” block manual valves (valves‐11) in Atm. Residue to fuel oil blending 10”‐RES‐011099004 (P&ID: 480138) For reference, see figure 1 VDU By‐pass sketch. ‐ Close the 8” two block manual valve in HAGO+LVGO line 8”‐HGO‐011098006 located downstream of PV‐0446A/B for segregate HAGO+LAGO rundown to Atm. Residue to fuel oil blender (P&ID: 480132). ‐ Align the HAGO line downstream of PV‐0446A/B to Slop but maintain the last block valve located in the slop header closed. In the scenario of S/D in the HP unit the diesel shall be going to slop. Note: During this operation the 100% HAGO has to go to HP HDS Unit 091 and the PV‐0446 outlet line is lined to slop. In the scenario HP HDS unit is in S/D o upset all the HAGO shall be going to slop.
(B) Change set point of E‐0031A/B outlet temperature controller (TC‐0175) to 150 ºC. (B) Change set point of E‐0030A/B outlet temperature controller (TC‐0173) to 100 ºC (atmospheric residue to fuel oil blender). STABLE STATE S2 Atmospheric Residue to Fuel oil Blender storage
INTERMEDIATE PROCEDURE FOR
VACUUM UNIT BY PASS UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0022 Date: 08‐DEC‐2011 Rev. : 01 Pag. : 13 of 20
LEVEL III STABLE STATE 2 SHEET STABLE STATE S2 Atmospheric Residue to Fuel oil Blender storage DESCRIPTION o Bottoms column level stabilized at its LLL, 850mm (around 18 % of 011‐LT‐0050 range), with means an inventory of around 10 m3 of Vacuum Residue (VR).
UTILITIES o Flushing Oil is available. o Closed drain and Amine drain systems are empty and available after the operational routine. Note: Maximize the inventory of flushing oil in storage because there will be a high demand during the planned VDU unit shutdown for dilution or cooling. 200 m3 approx. of flushing oil will be required.
Procedure No. 011‐IP‐0022 Date: 08‐DEC‐2011 Rev. : 01 Pag. : 14 of 20
INTERMEDIATE PROCEDURE FOR
VACUUM UNIT BY PASS UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
LEVEL III ACTIONS 300 011‐C‐0003 BOTTOMS FILL UP WITH FLUSHING OIL, DRAINING AND DEGASSING 310 Flushing Oil Procedure
(B) Introduce flushing oil inside the tower through the Flushing Oil Line, 4”‐FLO‐0110303026, flushing oil connection coming from FLO header directly connected to vacuum residue quench return line. Fill up with the proper level in the bottom to maximum visible on Level controller Bottom LC‐0050 and recalculing through the short recirculation line and the heater. LT‐0127 A has been relocated to provide more flexibility to the operator. Note: The tower will be filled up till reach approx. 4250mm (100 mm below HLCO, as a consequence, 38 m3 of FLO are required. Assuming a maximum flow rate of Flushing oil of 80000 kg/h, the timing necessary to introduce this quantity of FLO will be around 23 min. The estimated temperature of the mixture (residue + flushing oil) would be approx 130 ºC, without taking into account the remaining heat of the heater. o
(B) While the vacuum residue pumps is circulating around the vacuum heater and vacuum heater bottom, check the temperature of the bottom by means TT‐0203. Once the temperature is below to 300 ºC proceed with draining step.
320 Draining Procedure o (B) Open 4” manual block valve located in line 4”‐RES‐011039009 on vacuum residue line to LV‐0050 (P&ID: 480103). o (B) Open 4” manual block valve located in line 4”‐RES‐011039009 on vacuum residue line connect to slop header (P&ID: 480136). o (B) When the temperature of the bottom product is close to 300 ºC:
(F) Start emptying the bottom of the tower through 4” line to slop system using the control valve LV‐0050 located in line, 4” RES‐011039009‐103CL4P‐S (P&ID: 4800103).
(B) Decrease the set point of the level controller C‐0003 to a minimum possible gradually in order to minimize the tower inventory, through the HS‐0020 to allow C‐0003 draining to slop system during VDU By‐pass mode. Note: According to the expected inventory in the bottom of the column (around 48 m3), it has been estimated that the drain operation of the column will take around 60 min.
(F) Once the inventory has been reduced, stop G‐0018 Vacuum Residue Pump.
(F) Close HV‐0020 in the short recirculation line (10” RES‐01139004‐103CL4P‐S, P&ID: 480103).
(F) Drain the remaining hydrocarbons in the bottom of the tower through 4” line to close drain system, 4” CLD‐01130304‐101CH2S‐N, P&ID: 480081).
(F) Start the Drain Sump Pump (G‐0025). If it is required a portable pump in 4” flange to remove deeper liquids and connected the discharge to the discharge line of G‐0025, drain before.
INTERMEDIATE PROCEDURE FOR
VACUUM UNIT BY PASS UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1 330 Degassing Procedure
(F) Blow‐up the furnace by injecting steam.
(F) Stop the vacuum system.
(F) Close and isolate the Vacuum Tower and the Heater.
STATE FINAL VDU Bypassed
Procedure No. 011‐IP‐0022 Date: 08‐DEC‐2011 Rev. : 01 Pag. : 15 of 20
INTERMEDIATE PROCEDURE FOR
VACUUM UNIT BY PASS UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0022 Date: 08‐DEC‐2011 Rev. : 01 Pag. : 16 of 20
LEVEL III FINAL STATE SHEET FINAL STATE VDU Bypassed DESCRIPTION o CDU Unit at minimum flow (707.6 t/h). o VDU unit is bypassed. o Atmospheric Column level control in VDU‐bypass mode. o Set Point of 011‐E‐0031 and 011‐E‐0030 changed to Atmospheric residue to storage mode. o VDU Vacuum system stopped. o Vacuum tower and F‐0002 isolated. o Heat exchangers E‐0005/E‐0010/E‐0015/E‐0016/E‐0019 are by‐passed Note: Amine section status (including K‐0001) depends of the specific operational requirements. This section could be stopped, keeping in recirculation, out of operation, etc.
INTERMEDIATE PROCEDURE FOR
VACUUM UNIT BY PASS UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0022 Date: 08‐DEC‐2011 Rev. : 01 Pag. : 17 of 20
LEVEL IV Abbreviations CDU: Crude Distillation Unit VDU: Vacuum Distillation Unit LP: Low Pressure MP: Medium Pressure HP: High Pressure HLL: High liquid level BFW: Boiler Feed water WWT: Waste Water Treatment NHDT: Naphtha Hydrotreater HDS: Hydrodesulphurisation DHC: Distillate Hydrocracker MHC: Mild Hydrocracker LAGO: Light Atmospheric Crude HAGO: Heavy Atmospheric Crude LVGO: Light Vacuum Crude MVGO: Medium Vacuum Crude HVGO: Heavy Vacuum Crude PA: Pumparound BL: Battery Limit UC: Utility connection
INTERMEDIATE PROCEDURE FOR
VACUUM UNIT BY PASS UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0022 Date: 08‐DEC‐2011 Rev. : 01 Pag. : 18 of 20
PROCESS SCHEME
F-0001
LC 0020
G-0014A/B
C-0002
ATMOSPHERIC RESIDUE
FC
VALVE-3A
VALVE-1A
VALVE-2
FC
F-0002 HC 0020
4
LC 0050
12" BY-PASS VDU LINE
SHORT RECIRCULATION LINE
4" CLOSE DRAIN SYSTEM G-0018 A/B
C-0003
VALVE-3A
VALVE-4
LV-0050
VALVE-5
E-20 A-C/D-F
8"
VALVE-10
VALVE-8B
TO DCU
TO STORAGE
UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1 HAGO+LVGO TO HP HDS
VACUUM UNIT BY PASS
TO SLOP
HAGO+LVGO TO STORAGE
VALVE-11
To SLOP
To storage
TO DHC/MHC
INTERMEDIATE PROCEDURE FOR
HAGO + LVGO
PV-0446
DESALTED CRUDE
E-0031
VALVE-8A
VALVE 9B PV-0338
VALVE-7A
T WATER
E-30
E-0014 A-C/F-D
VALVE-6
VALVE 7B
VALVE-9A
E-0018 A-B/C-D
TOPPED CRUDE TOPPED CRUDE
TO 011-E-037
VALVE-1B
QUENCH LINE
MVGO + HVGO COOLERS
4" FLUSHING OIL
MVGO + LVGO
FIGURE 1. VDU BY-PASS SCHEME
Procedure No. 011‐IP‐0022 Date: 08‐DEC‐2011 Rev. : 01 Pag. : 19 of 20
INTERMEDIATE PROCEDURE FOR
VACUUM UNIT BY PASS UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0022 Date: 08‐DEC‐2011 Rev. : 01 Pag. : 20 of 20
BLIND LIST
CDU/VDU UNIT (UNIT 011) BLIND LIST Line number
P&ID
Service
2"‐HGO‐011099003‐103CS1P‐P 2"‐RES‐011099003‐103CS1P‐P 1"‐RES‐011030003‐101CL4P‐S 2"‐HGO‐011015006‐103CL2P‐S 2"‐CRD‐011015012‐106CL2P‐P 2"‐SLP‐011098016‐103CS1P‐P 2"‐SLP‐011098017‐103CS1P‐P 2"‐RES‐011030008‐101CM2P‐S 2"‐CRD‐011003009‐106CS1P‐P 3/4"‐LGO‐011030006‐101CS1P‐P 2"‐RES‐011040018‐103CS1P‐P 2"‐RES‐011040019‐103CS1P‐P 16"‐RES‐011040006‐103CS1P‐S 1"‐RES‐011027007‐103CL4P‐S 2"‐CRD‐011015004‐106CL2P‐P 2"‐HGO‐011099002‐103CS1P‐S 8"‐HGO‐011038005‐103CS1P‐S 2"‐RES‐011099002‐103CS1P‐S 12"‐HGO‐011039003‐103CL2P‐S 2"‐HGO‐011008001‐103CS1P‐P 2"‐RES‐011027008‐103CL4P‐S 1"‐RES‐011027008‐103CL4P‐S 2"‐RES‐011027007‐103CL4P‐S 12"‐CRD‐011015004‐106CL2P‐H 2"‐CRD‐011015009‐106CS2P‐P 2"‐HGO‐011015005‐103CL2P‐S 12"‐CRD‐011014003‐106CS2P‐H 12"‐HGO‐011015003‐103CL2P‐S 2"‐SLP‐011098011‐103CS1P‐S 2"‐SLP‐011098005‐103CS1P‐S 2"‐RES‐011027012‐103CL4P‐S 12"‐RES‐011027003‐103CL4P‐S 2"‐CRD‐011015011‐106CL2P‐P 2"‐BDH‐011040004‐101CS1P‐P 12"‐RES‐011039003‐103CL4P‐S 2"‐CRD‐011013007‐106CS1P‐P 12"‐CRD‐011015004‐106CL2P‐H 2"‐HGO‐011015007‐103CL2P‐S 12"‐HGO‐011015003‐103CL2P‐S 12"‐CRD‐011014003‐106CS2P‐H 2"‐HGO‐011015008‐103CL2P‐S 2"‐CRD‐011015010‐106CS2P‐P 2"‐CRD‐011015004‐106CL2P‐P 12"‐HGO‐011039003‐103CL2P‐S 2"‐CRD‐011013005‐106CS1P‐P 12"‐CRD‐011013002‐106CS1P‐H 12"‐CRD‐011013002‐106CS1P‐H 2"‐CRD‐011013006‐106CS1P‐P 2"‐HGO‐011013008‐103CL2P‐S 12"‐HGO‐011013003‐103CL2P‐S 8"‐SRW‐011044002‐106CH2S‐P 2"‐HGO‐011013022‐103CL2P‐P 2"‐KER‐011018003‐101CS1P‐P 6"‐BRN‐011042003‐101CS4P‐N 2"‐BRN‐011098001‐101CS4P‐N 2"‐LGO‐011098003‐103CS1P‐N 2"‐HGO‐011098007‐103CS1P‐N 6"‐LGO‐011037007‐103CS1P‐N 2"‐SWA‐011040302‐101CS1P‐N 12"‐HGO‐011013003‐103CL2P‐S
DS011‐TRJR‐480138 DS011‐TRJR‐480138 DS011‐TRJR‐480081 DS011‐TRJR‐480028 DS011‐TRJR‐480028 DS011‐TRJR‐480136 DS011‐TRJR‐480136 DS011‐TRJR‐480081 DS011‐TRJR‐480006 DS011‐TRJR‐480080 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480138 DS011‐TRJR‐480066 DS011‐TRJR‐480028 DS011‐TRJR‐480138 DS011‐TRJR‐480138 DS011‐TRJR‐480138 DS011‐TRJR‐480028 DS011‐TRJR‐480100 DS011‐TRJR‐480066 DS011‐TRJR‐480066 DS011‐TRJR‐480066 DS011‐TRJR‐480028 DS011‐TRJR‐480028 DS011‐TRJR‐480028 DS011‐TRJR‐480028 DS011‐TRJR‐480028 DS011‐TRJR‐480136 DS011‐TRJR‐480136 DS011‐TRJR‐480066 DS011‐TRJR‐480066 DS011‐TRJR‐480028 DS011‐TRJR‐480105 DS011‐TRJR‐480103 DS011‐TRJR‐480025 DS011‐TRJR‐480028 DS011‐TRJR‐480028 DS011‐TRJR‐480028 DS011‐TRJR‐480028 DS011‐TRJR‐480028 DS011‐TRJR‐480028 DS011‐TRJR‐480028 DS011‐TRJR‐480028 DS011‐TRJR‐480025 DS011‐TRJR‐480025 DS011‐TRJR‐480025 DS011‐TRJR‐480025 DS011‐TRJR‐480025 DS011‐TRJR‐480025 DS011‐TRJR‐480132 DS011‐TRJR‐480025 DS011‐TRJR‐480043 DS011‐TRJR‐480132 DS011‐TRJR‐480132 DS011‐TRJR‐480132 DS011‐TRJR‐480132 DS011‐TRJR‐480132 DS011‐TRJR‐480105 DS011‐TRJR‐480025
HEAVY GAS OIL RESIDUE VACUUM RESIDUE HVGO TOPPED CRUDE SLOP OIL SLOP OIL ATM. RESIDUE FRESH CRUDE LVGO VACUUM RESIDUE VACUUM RESIDUE VACUUM RESIDUE ATM. RESIDUE CRUDE HVGO HVGO VACUUM RESIDUE HVGO HEAVY GAS OIL ATM. RESIDUE ATM. RESIDUE ATM. RESIDUE TOPPED CRUDE TOPPED CRUDE HVGO TOPPED CRUDE HVGO SLOP OIL SLOP OIL ATM. RESIDUE ATM. RESIDUE TOPPED CRUDE WATER VACUUM RESIDUE TOPPED CRUDE TOPPED CRUDE HVGO HVGO TOPPED CRUDE HVGO TOPPED CRUDE CRUDE HVGO TOPPED CRUDE TOPPED CRUDE TOPPED CRUDE TOPPED CRUDE HVGO HVGO SOUR WATER HVGO KERO BRINE BRINE LVGO HAGO LVGO SERVICE WATER HVGO
CDU/VDU UNIT (UNIT 011) BLIND LIST Line number
P&ID
Service
2"‐HGO‐011013007‐103CL2P‐S 12"‐HGO‐011015003‐103CL2P‐S 3/4"‐NPH‐011018002‐101CH2S‐P 2"‐HGO‐011015003‐103CL2P‐P 12"‐HGO‐011015003‐103CL2P‐S 2"‐HGO‐011098008‐103CS1P‐N 2"‐RES‐011040010‐103CS1P‐S 3/4"‐OSW‐011040302‐101CS1P‐N 2"‐LGO‐011030005‐101CS1P‐S 2"‐HGO‐011030004‐101CL2P‐S 2"‐RES‐011040003‐103CS1P‐P 3/4"‐OSW‐011040304‐101CS1P‐N 12"‐LPS‐011040003‐101CS1P‐H 10"‐RES‐011040003‐103CS1P‐S 2"‐RES‐011040012‐103CS1P‐S 10"‐RES‐011040006‐103CS1P‐S 2"‐RES‐011040002‐103CS1P‐P 2"‐RES‐011040009‐103CH2S‐S 2"‐RES‐011040008‐103CH2S‐S 2"‐RES‐011040011‐103CS1P‐S 3/4"‐OSW‐011040303‐101CS1P‐N 12"‐RES‐011027003‐103CL4P‐S 18"‐RES‐011027001‐103CL4P‐S 4"‐MPS‐011030301‐103CS1P‐H 6"‐RES‐011030002‐101CL4P‐S 3/4"‐RES‐011030003‐101CL4P‐S 4"‐RES‐011030003‐101CL4P‐S 2"‐HGO‐011013011‐103CL2P‐S 2"‐VAC‐011030003‐101CH4S‐P 10"‐RES‐011040001‐103CS1P‐S 12"‐LPS‐011040002‐101CS1P‐H 3/4"‐LPS‐011040013‐101CS1P‐H 6"‐BFW‐011040001‐101CS1P‐H 2"‐RES‐011040005‐103CS1P‐P 2"‐LGO‐011030003‐103CS1P‐N 2"‐RES‐011030009‐101CM2P‐P 16"‐RES‐011039001‐103CL4P‐S 2"‐RES‐011040001‐103CS1P‐P 10"‐RES‐011040003‐103CS1P‐S 6"‐BFW‐011040002‐101CS1P‐H 6"‐SRW‐011044003‐106CH2S‐P 6"‐SRW‐011044004‐106CH2S‐P 3/4"‐SRW‐011044008‐106CH2S‐P 2"‐SRW‐011044008‐106CH2S‐P 3/4"‐SRW‐011044009‐106CH2S‐P 2"‐SRW‐011044009‐106CH2S‐P 2"‐BDH‐011040005‐101CS1P‐P 3/4"‐HGO‐011030007‐101SD0P‐S 2"‐HGO‐011030007‐101SD0P‐S 2"‐RES‐011039004‐103CL4P‐P 12"‐RES‐011039003‐103CL4P‐S 2"‐RES‐011039002‐103CL4P‐P 2"‐RES‐011039001‐103CL4P‐P 4"‐RES‐011030001‐103CL4P‐P 1"‐INH‐011054002‐101SC1P‐N 3/4"‐OSW‐011040308‐101CS1P‐N 2"‐RES‐011039007‐103CL4P‐S 3/4"‐RES‐011039007‐103CL4P‐S 3/4"‐RES‐011039008‐103CL4P‐S 2"‐RES‐011039008‐103CL4P‐S
DS011‐TRJR‐480025 DS011‐TRJR‐480025 DS011‐TRJR‐480043 DS011‐TRJR‐480025 DS011‐TRJR‐480025 DS011‐TRJR‐480132 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480080 DS011‐TRJR‐480080 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480066 DS011‐TRJR‐480066 DS011‐TRJR‐480081 DS011‐TRJR‐480081 DS011‐TRJR‐480081 DS011‐TRJR‐480081 DS011‐TRJR‐480024 DS011‐TRJR‐480080 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480080 DS011‐TRJR‐480081 DS011‐TRJR‐480103 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480114 DS011‐TRJR‐480114 DS011‐TRJR‐480114 DS011‐TRJR‐480114 DS011‐TRJR‐480114 DS011‐TRJR‐480114 DS011‐TRJR‐480105 DS011‐TRJR‐480081 DS011‐TRJR‐480081 DS011‐TRJR‐480103 DS011‐TRJR‐480103 DS011‐TRJR‐480103 DS011‐TRJR‐480103 DS011‐TRJR‐480103 DS011‐TRJR‐480043 DS011‐TRJR‐480104 DS011‐TRJR‐480103 DS011‐TRJR‐480103 DS011‐TRJR‐480103 DS011‐TRJR‐480103
HVGO HVGO HEAVY NAPHTHA HEAVY GAS OIL HVGO HAGO VACUUM RESIDUE WATER LVGO MVGO RESIDUE WATER LP STEAM VACUUM RESIDUE VACUUM RESIDUE VACUUM RESIDUE RESIDUE VACUUM RESIDUE VACUUM RESIDUE VACUUM RESIDUE WATER ATM. RESIDUE ATM. RESIDUE MP STEAM VACUUM RESIDUE VACUUM RESIDUE VACUUM RESIDUE HVGO VDU OFF GAS VACUUM RESIDUE LP STEAM LP STEAM BOILER FEED WATER RESIDUE LVGO RESIDUE VACUUM RESIDUE RESIDUE VACUUM RESIDUE BOILER FEED WATER SOUR WATER SOUR WATER SOUR WATER SOUR WATER SOUR WATER SOUR WATER WATER HVGO HVGO RESIDUE VACUUM RESIDUE RESIDUE RESIDUE RESIDUE CORROSION INHIBITOR WATER VACUUM RESIDUE RESIDUE RESIDUE VACUUM RESIDUE
CDU/VDU UNIT (UNIT 011) BLIND LIST Line number
P&ID
Service
8"‐HGO‐011025003‐103CS1P‐N 8"‐HGO‐011098006‐103CS1P‐N 6"‐WST‐011098001‐101CS2P‐N 3/4"‐HGO‐011030010‐101CL2P‐P 2"‐HGO‐011038004‐103CS1P‐P 3/4"‐NPH‐011018002‐101CH2S‐P 3"‐NPH‐011098001‐103CH2S‐P 6"‐RES‐011014004‐101CL2P‐S 24"‐LPS‐011041006‐101CS1P‐H 24"‐LPS‐011041006‐101CS1P‐H 2"‐SWA‐011040301‐101CS1P‐N 2"‐CRD‐011015025‐106CS2P‐P 2"‐HGO‐011015009‐103CL2P‐P 2"‐HGO‐011038015‐103CS1P‐S 2"‐HGO‐011038016‐103CS1P‐S 24"‐HGO‐011030001‐101CL2P‐S 24"‐HGO‐011030001‐101CL2P‐S 2"‐CLD‐011078325‐101CH2S‐N 2"‐CLD‐011078326‐101CH2S‐N 12"‐KER‐011004001‐101CS1P‐H 12"‐KER‐011004001‐101CS1P‐H 16"‐KER‐011022002‐101CS1P‐H 16"‐SLP‐011098001‐103CS1P‐S 2"‐HGO‐011013023‐103CL2P‐P 3/4"‐RES‐011030008‐101CM2P‐S 2"‐HGO‐011015003‐103CL2P‐P 2"‐LGO‐011018004‐103CS1P‐P 2"‐KER‐011018002‐101CS1P‐P 3/4"‐HGO‐011030009‐101SD0P‐S 2"‐OSW‐011051301‐101CS1P‐N 2"‐SRW‐011044016‐106CH2S‐P 3"‐NPH‐011019008‐101CH2S‐P 1"‐CHP‐011054002‐101SC1P‐N 2"‐NPH‐011018003‐101CH2S‐P 3/4"‐NPH‐011018002‐101CH2S‐P 3/4"‐NPH‐011018002‐101CH2S‐P 3/4"‐NPH‐011018002‐101CH2S‐P 3/4"‐NPH‐011018002‐101CH2S‐P 3/4"‐NPH‐011018002‐101CH2S‐P 3/4"‐NPH‐011018002‐101CH2S‐P 8"‐RES‐011030009‐101CM2P‐S 6"‐HGO‐011039008‐101SD0P‐S 2"‐RES‐011039005‐101CL4P‐S 2"‐CRD‐011015026‐106CS2P‐P 2"‐HGO‐011015010‐106CS2P‐P 2"‐CLD‐011078330‐101CH2S‐P 2"‐CRD‐011013008‐106CS1P‐P 8"‐SLP‐011098003‐103CS1P‐S 1"‐RES‐011030007‐101CL4P‐S 6"‐SRW‐011044002‐106CH2S‐P 6"‐SRW‐011044015‐106CH2S‐P 3/4"‐KER‐011018301‐101CS1P‐P 2"‐LGO‐011018003‐101CS1P‐P 3/4"‐OSW‐011040309‐101CS1P‐N 8"‐RES‐011030009‐101CM2P‐S 2"‐HGO‐011039003‐103CL2P‐P 1"‐RES‐011030010‐101CL4P‐S 1"‐RES‐011030003‐101CL4P‐S 1"‐VAC‐011030003‐101CH4S‐P 1"‐VAC‐011030003‐101CH4S‐P
DS011‐TRJR‐480132 DS011‐TRJR‐480132 DS011‐TRJR‐480132 DS011‐TRJR‐480080 DS011‐TRJR‐480100 DS011‐TRJR‐480043 DS011‐TRJR‐480043 DS011‐TRJR‐480081 DS011‐TRJR‐480081 DS011‐TRJR‐480081 DS011‐TRJR‐480105 DS011‐TRJR‐480028 DS011‐TRJR‐480028 DS011‐TRJR‐480100 DS011‐TRJR‐480100 DS011‐TRJR‐480081 DS011‐TRJR‐480081 DS011‐TRJR‐480229 DS011‐TRJR‐480229 DS011‐TRJR‐480043 DS011‐TRJR‐480043 DS011‐TRJR‐480043 DS011‐TRJR‐480136 DS011‐TRJR‐480025 DS011‐TRJR‐480081 DS011‐TRJR‐480025 DS011‐TRJR‐480043 DS011‐TRJR‐480043 DS011‐TRJR‐480081 DS011‐TRJR‐480121 DS011‐TRJR‐480114 DS011‐TRJR‐480043 DS011‐TRJR‐480043 DS011‐TRJR‐480043 DS011‐TRJR‐480043 DS011‐TRJR‐480043 DS011‐TRJR‐480043 DS011‐TRJR‐480043 DS011‐TRJR‐480043 DS011‐TRJR‐480043 DS011‐TRJR‐480081 DS011‐TRJR‐480081 DS011‐TRJR‐480081 DS011‐TRJR‐480028 DS011‐TRJR‐480028 DS011‐TRJR‐480227 DS011‐TRJR‐480025 DS011‐TRJR‐480136 DS011‐TRJR‐480081 DS011‐TRJR‐480114 DS011‐TRJR‐480114 DS011‐TRJR‐480043 DS011‐TRJR‐480043 DS011‐TRJR‐480104 DS011‐TRJR‐480081 DS011‐TRJR‐480028 DS011‐TRJR‐480081 DS011‐TRJR‐480081 DS011‐TRJR‐480080 DS011‐TRJR‐480080
HAGO HAGO STRIPPED SOUR WATER MVGO HEAVY GAS OIL HEAVY NAPHTHA HEAVY NAPHTHA VACUUM RESIDUE LP STEAM LP STEAM SERVICE WATER TOPPED CRUDE HVGO HVGO HVGO HVGO HVGO HC CLOSED DRAIN HC CLOSED DRAIN KERO KERO KERO SLOP OIL HVGO RESIDUE HEAVY GAS OIL LAGO KERO HVGO WATER SOUR WATER NAPHTHA NEUTRALIZING AGENT NAPHTHA HEAVY NAPHTHA HEAVY NAPHTHA HEAVY NAPHTHA HEAVY NAPHTHA HEAVY NAPHTHA HEAVY NAPHTHA ATM. RESIDUE HVGO VACUUM RESIDUE TOPPED CRUDE HVGO HC CLOSED DRAIN TOPPED CRUDE SLOP OIL ATM. RESIDUE SOUR WATER SOUR WATER KERO LIGHT GAS OIL WATER ATM. RESIDUE HEAVY GAS OIL ATM. RESIDUE VACUUM RESIDUE VDU OFF GAS VDU OFF GAS
CDU/VDU UNIT (UNIT 011) BLIND LIST Line number
P&ID
Service
1"‐VAC‐011030003‐101CH4S‐P 1"‐VAC‐011030003‐101CH4S‐P 14"‐LGO‐011030001‐101CS1P‐H 10"‐LGO‐011030002‐101CS1P‐P 14"‐LGO‐011030001‐101CS1P‐H 6"‐LGO‐011037004‐101CS1P‐H 14"‐HGO‐011013006‐101SD0P‐S 8"‐HGO‐011030002‐101CL2P‐S 56"‐VAC‐011030001‐101CH4S‐P 56"‐VAC‐011030002‐101CH4S‐P 2"‐RES‐011027005‐103CL4P‐P 6"‐LPS‐011040006‐101CS1P‐P 2"‐HGO‐011098015‐103CS1P‐N 3"‐BFW‐011040302‐101CS1P‐P 10"‐LPS‐011040004‐101CS1P‐H 2"‐BDH‐011040002‐101CS1P‐P 2"‐BDH‐011040001‐101CS1P‐P 6"‐BFW‐011040002‐101CS1P‐H 6"‐BFW‐011040001‐101CS1P‐H 2"‐FLO‐011040307‐101CS1P‐N 1"‐CHP‐011054003‐101SC1P‐N 1"‐CHP‐011054003‐101SC1P‐N 2"‐HGO‐011039003‐103CL2P‐P 12"‐LGO‐011018003‐101CS1P‐H 12"‐LGO‐011018003‐101CS1P‐H 8"‐KER‐011026002‐101CS1P‐H 2"‐RES‐011027001‐103CL4P‐P 12"‐RES‐011027006‐103CL4P‐S 18"‐RES‐011027002‐103CL4P‐S 2"‐RES‐011027002‐103CL4P‐P 2"‐CRD‐011013011‐106CS1P‐P 2"‐HGO‐011013021‐103CS1P‐S 14"‐LGO‐011023002‐101CS1P‐H 6"‐NPH‐011019007‐101CH2S‐P 24"‐KER‐011018001‐101CS1P‐H 24"‐KER‐011018001‐101CS1P‐H 40"‐NPH‐011018001‐101CH2S‐P 2"‐RES‐011040015‐103CS1P‐S 2"‐RES‐011040016‐103CS1P‐S 6"‐SLP‐011099001‐103CS1P‐P 16"‐RES‐011039002‐103CL4P‐S 12"‐RES‐011039006‐103CL4P‐S 2"‐SLP‐011098013‐103CS1P‐S 2"‐CRD‐011003008‐106CS1P‐P 4"‐RES‐011027021‐103CL4P‐S 4"‐RES‐011027022‐103CL4P‐S 4"‐LGO‐011030002‐101CS1P‐P 24"‐VAC‐011030003‐101CH4S‐P 2"‐HGO‐011038005‐103CS1P‐P 2"‐SLP‐011098018‐103CS1P‐S 2"‐FLO‐011040306‐101CS1P‐N
DS011‐TRJR‐480080 DS011‐TRJR‐480080 DS011‐TRJR‐480080 DS011‐TRJR‐480080 DS011‐TRJR‐480080 DS011‐TRJR‐480080 DS011‐TRJR‐480080 DS011‐TRJR‐480080 DS011‐TRJR‐480080 DS011‐TRJR‐480080 DS011‐TRJR‐480066 DS011‐TRJR‐480105 DS011‐TRJR‐480132 DS011‐TRJR‐480105 DS011‐TRJR‐480105 DS011‐TRJR‐480105 DS011‐TRJR‐480105 DS011‐TRJR‐480105 DS011‐TRJR‐480105 DS011‐TRJR‐480104 DS011‐TRJR‐480080 DS011‐TRJR‐480080 DS011‐TRJR‐480028 DS011‐TRJR‐480043 DS011‐TRJR‐480043 DS011‐TRJR‐480043 DS011‐TRJR‐480066 DS011‐TRJR‐480066 DS011‐TRJR‐480066 DS011‐TRJR‐480066 DS011‐TRJR‐480024 DS011‐TRJR‐480024 DS011‐TRJR‐480043 DS011‐TRJR‐480043 DS011‐TRJR‐480043 DS011‐TRJR‐480043 DS011‐TRJR‐480043 DS011‐TRJR‐480104 DS011‐TRJR‐480104 DS011‐TRJR‐480138 DS011‐TRJR‐480103 DS011‐TRJR‐480103 DS011‐TRJR‐480136 DS011‐TRJR‐480006 DS011‐TRJR‐480066 DS011‐TRJR‐480066 DS011‐TRJR‐480080 DS011‐TRJR‐480080 DS011‐TRJR‐480100 DS011‐TRJR‐480136 DS011‐TRJR‐480104
VDU OFF GAS VDU OFF GAS LVGO LVGO LVGO LVGO HVGO MVGO VDU OFF GAS VDU OFF GAS RESIDUE LP STEAM HAGO BOILER FEED WATER LP STEAM WATER WATER BOILER FEED WATER BOILER FEED WATER FLUSHING OIL NEUTRALIZING AGENT NEUTRALIZING AGENT HEAVY GAS OIL LAGO LAGO KERO RESIDUE ATM. RESIDUE ATM. RESIDUE RESIDUE TOPPED CRUDE HVGO LAGO NAPHTHA KERO KERO HEAVY NAPHTHA VACUUM RESIDUE VACUUM RESIDUE SLOP OIL VACUUM RESIDUE VACUUM RESIDUE SLOP OIL FRESH CRUDE ATM. RESIDUE ATM. RESIDUE LIGHT GAS OIL VDU OFF GAS HEAVY GAS OIL SLOP OIL FLUSHING OIL
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 41.
GENERAL EMERGENCY SHUTDOWN Document Number
Description
SA-JER-DS011-TRJR-400011
GENERAL EMERGENCY SHUTDOWN
Rev. 01
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 42.
LOSS OF INSTRUMENT AIR Document Number
Description
SA-JER-DS011-TRJR-400012
LOSS OF INSTRUMENT AIR
Rev. 01
ORIGINAL SIGNED IN PROJECT FILE
INCIDENT STRATEGY FOR:
LOSS OF INSTRUMENT AIR UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0026 Date: 10‐Nov‐2011 Rev. : 01 Pag. : 1 of 4
DOCUMENT: SA‐JER‐DS011‐TRJR‐400012
INCIDENT STRATEGY FOR:
LOSS OF INSTRUMENT AIR UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Note: This document does not replace the corresponding “Emergency Card” which will be developed by SATORP. REVISION CONTROL REV. 01 00
DATE 10‐NOV‐2011 06‐JUL‐2011
DESCRIPTION APPROVED FOR CONSTRUCTION ISSUE FOR REVIEW
PREPARED BY
CHECKED BY
APPROVED BY
Miguel Ángel Castro
José Luis Roldán
Juan Lechuga
DISCIPLINE CODE PRO Document Class: 2
DOCUMENT TYPE MAN
UNIT 011
SYSTEM
Legend
o ◊
Action Verification Safety Action
B – Board Operator F – Field Operator S – Shift Supervisor
INCIDENT STRATEGY FOR:
LOSS OF INSTRUMENT AIR UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0026 Date: 10‐Nov‐2011 Rev. : 01 Pag. : 2 of 4
IDENTIFICATION INDICATION o
(B) Low pressure at Instrument air supply battery limit detected by PAL‐0279.
CONFIRMATION The following verification could be used as confirmation of the event: o (F) Low pressure read in PI‐0278. o (F) Low flow read in FI‐0098.
IMMEDIATE ACTIONS Note: In the event of an instrument air failure, each pneumatic valve (on‐off and control valves) should fail to its safe position. A complete failure of instrument air is unlikely.
Try to mitigate the cause of the upset: ‐ Restore the Instrument Air supply (i.e. (B/F) check that the pathway through the Instrument air system is open; (S/B) communicate with Instrument air supply unit operator to detect the incidence source). ‐ (F) Check for leaks and other upsets. ‐ (B) Re‐establish all control and on‐off valves to initial position before incident. ‐ (B/F) Start‐up the unit.
In case that the contingence could not be mitigated immediately, due to an event of a total instrument air failure, the following action must be taken o (B) Verify that all the control and on‐off valves will adapt the safe position. o (B/F) Verify that crude feed is blocked; ZV‐0046 (crude oil from battery limit) and FV‐0175 (slop from storage) are closed. Note: In case of instrument air failure the pre‐heater train is blocked outlet by on‐off valve ZV‐0085 closed, the safety valve TZV‐0013 (locate downstream E‐0009) has a design case for over pressure, due to heat transfer don’t stop immediately. o
(B) Verify that interlock ZC‐0331 / ZC‐0335 (furnaces F‐0001 and F‐0002 tripped respectively and ensure that HV‐0015 open accordingly), due to low pilot gas pressure (Through PI‐ 0132/0191 for F‐0001 and PI‐0219/0225 for F‐0002), check the action and changes the position of the following valves: Close pilot gas to heaters F‐0001/F‐0002, by closing ZV‐0034/0033, ZV‐ 0053/0051 (cell 1 and 2 heater F‐0001) and ZV‐0061/0059, ZV‐0069/0067 (cell 1 and 2 heater F‐0002).
INCIDENT STRATEGY FOR:
LOSS OF INSTRUMENT AIR UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0026 Date: 10‐Nov‐2011 Rev. : 01 Pag. : 3 of 4
o o o o
o
o
Close fuel gas to heaters F‐0001/F‐0002, by closing ZV‐0036/0037, ZV‐ 0054/0056 (cell 1 and 2 heater F‐0001) and ZV‐0062/0064, ZV‐0070/0072 (cell 1 and 2 heater F‐0002). Close vent gas to heater F‐0002, by closing ZV‐0030. Open pilot gas to atmosphere at safe location, by opening ZV‐0032 / ZV‐0052 (cell 1 and 2 heater F‐0001) and opening ZV‐0060 / ZV‐0068 (cell 1 and 2 heater F‐0002). Stop the combustion air forced fans, K‐0002A/B/C. Stop the flue gas induced fan, K‐0003.
(B) Verify that cooling water has been maintained to vacuum systems exchangers E‐ 0025/0026/0027/0028, E‐0021, E‐0036, E‐0029. (B) Verify that the compressor K‐0001 continues running in order to mitigate the increase of pressure downstream. (B) Verify that air cooler are running. (B) Verify that all pump around of columns C‐0002 are stopped: ZV‐0077 closed, stop pump G‐0008 A/B (column C‐0002) ZV‐0078 closed, stop pump G‐0010 A/B (column C‐0002) ZV‐0079 closed, stop pump G‐0012 A/B (column C‐0002) (B) Verify that all products are stopped: ZV‐0009 closed, stop pump G‐0007 A/B (Naphtha Product) ZV‐0011 closed, stop pump G‐0009 A/B (Kerosene Product) ZV‐0078 closed, stop pump G‐0011 A/B (LAGO Product) ZV‐0080 closed, stop pump G‐0013 A/B (HAGO Product) ZV‐0083 closed, stop pump G‐0015 A/B (LVGO Product) ZV‐0086 closed, stop pump G‐0016 A/B (MVGO Product) ZV‐0081 closed, stop pump G‐0017 A/B (HVGO Product) ZV‐0016 closed, stop pump G‐0018 A/B (VAC RESID) (B) Verify that column levels on bottom has been maintained: C‐0001 bottom ZV‐0002, closed. C‐0002 bottom ZV‐0006, closed. C‐0003 bottom ZV‐0016, closed. C‐0004 bottom ZV‐0011, closed. C‐0005 bottom blocked with flow control valve FV‐0030 and FV‐0119, located E‐0034 downstream, closed. C‐0006 bottom ZV‐0080, closed. C‐0007 bottom ZV‐0112, closed.
Note: If the air failure continues more than a few minutes, consider whether a total shutdown is necessary. If a total shutdown is necessary the opportunity should be taken to check that all valves have reverted to their correct failure positions.
UNIT STATUS If the contingence could be mitigated in a short period of time, the unit capacity can be recovered as it was working before the incident. If the contingence cannot be mitigated immediately, the CDU/VDU status is:
INCIDENT STRATEGY FOR:
LOSS OF INSTRUMENT AIR UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0026 Date: 10‐Nov‐2011 Rev. : 01 Pag. : 4 of 4
‐ ‐ ‐ ‐ ‐
Crude feed to G‐0001 stopped. Heaters stopped, fuel gas and pilot gas to heater F‐0001 and F‐0002 are closed. On‐Off and control valves in its safe position. Air cooler running. Pump around and product stopped.
FOLLOW UP ACTIONS In case the contingence could be mitigated, monitor the temperature / pressure profile of the unit in order to detect any upset. If the contingence cannot be mitigated immediately a total shutdown is necessary.
ISOLATE As required. If the contingency can be mitigated in a short period of time, isolation is not required.
POST INCIDENT PLAN After the instrument air is recovered, proceed to start up the unit.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 43.
LOSS OF PILOT GAS Document Number
Description
SA-JER-DS011-TRJR-400013
LOSS OF PILOT GAS
Rev. 01
INClDENT STRATEGY FOR:
LOSS OF PILOT GAS UNlT 0 1 1 - CRUDE DlSTlLLATlON UNlTTRAlN 1
Procedure No. 011-IP-O027 Date: 10-NOV-2011 Rev. : 0 1 Pag. : 1of 4
DOCUMENT: SA-JER-DS011-TRJR-400013
INCIDENT STRATEGY FOR:
LOSS OF PlLOT GAS UNlT 011 - CRUDE DlSTlLLATlON UNlT TRAIN 1
Note: This docurnent does not replace the corresponding "Ernergency Card" which wiil be developed by SATORP.
DATE
REV.
DESCRIPTION APPROVED FOR CONSTRUCTION iSSUE FOR REVIEW
Document Class: 2
/ Legend
r
U o O
Action Verification Safety Action
; B - Board Operator .)
/
F - Field Operator S -Shift S u p e ~ i s o r
INCIDENT STRATEGY FOR:
LOSS OF PILOT GAS
.
UNiT011- CRUDE DlSTiLLATlON UNlTTRAlN 1
Procedure No. 011-IP-O027 Date: 10-NOV-2011 Rev. : 01 Pag. : 2 of 4
IDENTIFICATION Note: The development of this strategy considers that the cause of this lncldent 1s Piiot Gas supply fallure from Battery Limit; other upsets regarding t o a loss of piiot gas, in the heaters, can be identified asan erring operational procedure e.g: ZV biockage or ciosure o f a manuai valve due to an operational mistake.
o o o o o
(E) Low pressure at piiot gas supply battery limit detected by PAL-0284. [E) Low pressure at pilot gas supply to heater F-0001 cell 1detected by PAL-0138. (E) Low pressure at piiot gas suppiy to heater F-0001cell2 detected by PAL-0192. (E) Low pressure at piiot gas suppiy to heater F-0002 cell 1detected by PAL-0210. (B) Low pressure at piiot gas supply to heater F-0002 cell2 detected by PAL-0226.
The following verification could be used as confirmation of the event:
o o o o
(F/B) ZV-0102 is not in safe position (iocated on BL). (F) Low pressure read in Pi-0283, beiow 4 barg (located on EL). (F/B) Low pressure read in PT-0284, below 4 barg (located on BL). (8) Lowfiow read in FI-0102, below 43.5 sm3/h (Located on BL).
Note: I f the PAL-0284 has not trlpped and ZV-0102 has not failed l n safe position, (F) has t o check and confirm with (B) the opening value of: PCV-0141/ 0389 / 0195 / 0394 / 0398 / 0214 / 0404 / 0227,ZV-0033 10034 / 0051 / 0053 / 0059 / 0061 / 0067 / 0069, filter piugging and manual valves position, due t o the loss of Piiot Gas could be caused by a mistake in the operational procedure. (F) Shouid check the PDi of the PiG strainer and do the swltchlng and cleaning o f the strainer.
n
(B) Notify al1 the process units (NHDT, LP HDS, HP HOS, DHCIMHC and OCU) and utilities about the incident. (B) Decrease the crude feed gradually by mean FC-0006.
Note: If the pilot gas supply pressure drops too far, heaters F-0001and F-0002 in the COU/VOU unit wili trip automatically thought the interlock activation ZC-0331 and ZC-0335 respectiveiy.
I I I
Try to mitigate the cause of the upset: O Restore the pilot gas supply (¡.e. (B/F) check that the pathway through the pilot gas system is open; (S/@ communicate with pilot gas suppiy unit operator t o detect the incidente source).
a
(8) Re-estabiish al1 control and on-off vaives t o initiai position before incident.
O
(BIF) Restart the heaters immediateiy taking the following actions: (F) Reset the following during start-up: PALL-0132 and PALL-0191(piiot gas pressure heater F-0001 Cell A and 8) PALL-0219 and PALL-O225 (piiot gas pressure heater F-0002 Cell A and E)
INCIDENTSTRATEGY FOR:
LOSS OF PILOT GAS UNlT 011 - CRUDE DlSTlLLATlON UNlT TRAIN 1
ISOLATE
1
If the contingency can be mitigated in a short period of time, isolation is not required.
POST INCIDENT PLAN After the pilot gas is recovered, proceed t o the start-up of the unit
Procedure No. 011-IP-O027 Date: 10-NOV-2011 Rev. : 0 1 Pag. : 4 of 4
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 44.
LOSS OF POWER ELECTRIC SYSTEM Document Number
Description
SA-JER-DS011-TRJR-400014
LOSS OF POWER ELECTRIC SYSTEM
Rev. 01
ORIGINAL SIGNED IN PROJECT FILE INCIDENT STRATEGY FOR:
LOSS OF POWER ELECTRIC SYSTEM UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0028 Date: 23‐NOV‐2011 Rev. : 01 Pag. : 1 of 4
DOCUMENT: SA‐JER‐DS011‐TRJR‐400014
INCIDENT STRATEGY FOR:
LOSS OF POWER ELECTRIC SYSTEM UNIT 011 – CRUDE DISTILLATION UNIT
Note: This document does not replace the corresponding “Emergency Card” which will be developed by SATORP. REVISION CONTROL REV. 01 00
DATE 23‐NOV‐2011 21‐JUL‐2011
DESCRIPTION APPROVED FOR CONSTRUCTION ISSUE FOR REVIEW
PREPARED BY
CHECKED BY
APPROVED BY
Tulio Hernández
Miguel Ángel Castro
Juan Lechuga
DISCIPLINE CODE PRO Document Class: 2
DOCUMENT TYPE MAN
UNIT 011
SYSTEM
Legend
o ◊
Action Verification Safety Action
B – Board Operator F – Field Operator S – Shift Supervisor
INCIDENT STRATEGY FOR:
LOSS OF POWER ELECTRIC SYSTEM UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0028 Date: 23‐NOV‐2011 Rev. : 01 Pag. : 2 of 4
IDENTIFICATION
INDICATION o o
(B) Several alarms will be displayed in the DCS due to the stoppage of the pumps, VDU off‐gas compressor, heaters fan and air coolers. (B) Running status of all motors will indicate the stoppage.
CONFIRMATION o o o o o
(B) Confirm the no/low flows at the discharge of the pumps and VDU off‐gas compressor. (B) Confirm the high temperature at the outlet of the air coolers. (F) Confirm that the pumps, VDU off‐gas compressor and/or air coolers are stopped. (B) Confirm columns top temperature. (B) Confirm columns bottom level increase.
IMMEDIATE ACTIONS Note: In total power failure, the CDU/VDU unit loses its feed and will shut down safely. Several interlocks will be initiated due to the process deviations caused by a power failure. Pressure safety valves on the preflash column C‐0001, crude column C‐0002 and vacuum column C‐0003, PZV‐0005/06, PZV‐0046/47 and PZV‐0019/20 respectively, are expected to relieve in the event of total power failure. Note: Several interlocks will be initiated due to the process deviations caused by a power failure. The unit should be put in a safe standby mode following the steps below: o (B) Verify that all motor driver pumps and air cooler fan stop. o (B) Verify that power to the Desalters is lost (B/F) Ensure the furnaces F‐0001 and F‐0002 stopped firing. o (F) Verify that 011‐UC‐0332 has trigger HV‐0015. (B) Divert the stripping steam to the silencers as it may condense through the heater convection coils. o (B) Confirm the expected duration of power outage. If it is less than 15 minutes, the Crude Feed flow may be recovered at the normal rate. In case of total power failure for long time the Unit Shut down will be implemented and 011‐IP‐0025 shall be followed. Note: In case of partial power failure there are two parallel feeders are set up for each of 4.16 kV and 480V. Two pump motors paired as “A” and “B” are hooked up to Bus 1 and Bus 2, respectively. As most of the paired pumps are set up, in case of partial power failure spare pump on the other feeder will come on stream. This arrangement essentially eliminates the possibility of plant upset similar to total power failure. In CDU/VDU unit all pump without “auto‐start” features, this can be re‐started manually. Each pair or air cooler fan motors in each bay is hooked up to two separate feeder buses. Therefore, loss of one feeder causes loss of half of the air cooler.
INCIDENT STRATEGY FOR:
LOSS OF POWER ELECTRIC SYSTEM UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0028 Date: 23‐NOV‐2011 Rev. : 01 Pag. : 3 of 4
If Partial power failure occurs: o (B) Confirm that pumps, fan of air cooler or VDU off‐gas compressor stopped are hooked up to Bus 1 or Bus 2, according the following tables: TABLE 1.‐ CDU/VDU PROCESS PUMP MOTOR BUS A BUS B 011‐G‐0001 A 011‐G‐0001 B 011‐G‐0002 B 011‐G‐0002 A 011‐G‐0003 B 011‐G‐0003 A 011‐G‐0004 B 011‐G‐0004 A 011‐G‐0005 B 011‐G‐0005 A 011‐G‐0006 B 011‐G‐0006 A 011‐G‐0007 B 011‐G‐0007 A 011‐G‐0008 A 011‐G‐0008 B 011‐G‐0009 A 011‐G‐0009 B 011‐G‐0010 A 011‐G‐0010 B 011‐G‐0011 B 011‐G‐0011 A 011‐G‐0012 A 011‐G‐0012 B 011‐G‐0013 B 011‐G‐0013 A 011‐G‐0014 B 011‐G‐0014 A 011‐G‐0015 A 011‐G‐0015 B 011‐G‐0016 A 011‐G‐0016 B 011‐G‐0017 A 011‐G‐0017 B 011‐G‐0018 A 011‐G‐0018 B 011‐G‐0019 A 011‐G‐0019 B 011‐G‐0020 B 011‐G‐0020 A 011‐G‐0021 B 011‐G‐0021 A 011‐G‐0022 B 011‐G‐0022 A 011‐G‐0023 A 011‐G‐0023 B 011‐G‐0024 A 011‐G‐0024 B 011‐G‐0025 B 011‐G‐0025 A 011‐G‐0026 B 011‐G‐0026 A 011‐G‐0027 ‐ 011‐G‐0028 A 011‐G‐0028 B TABLE 2.‐ CDU/VDU AIR COOLER FAN MOTOR AIR COOLER 011‐A‐0001 011‐A‐0002 011‐A‐0003 011‐A‐0004 011‐A‐0005 011‐A‐0006 011‐A‐0007 011‐A‐0008
BUS A 011‐MA‐0001 A/C/E/G/K/M/P 011‐MA‐0002 A/C/E 011‐MA‐0003 A 011‐MA‐0004 A 011‐MA‐0005 A/C/E/G 011‐MA‐0006 A 011‐MA‐0007 A/C/E 011‐MA‐0008
BUS B 011‐MA‐0001 B/D/F/H/J/L/N/Q 011‐MA‐0002 B/D/F 011‐MA‐0003 B 011‐MA‐0004 B 011‐MA‐0005 B/D/F/H 011‐MA‐0006 B 011‐MA‐0007 B/D/F ‐
INCIDENT STRATEGY FOR:
LOSS OF POWER ELECTRIC SYSTEM UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0028 Date: 23‐NOV‐2011 Rev. : 01 Pag. : 4 of 4
TABLE 3.‐ CDU/VDU COMPRESSOR AND FAN MOTOR FAN 011‐K‐0001 011‐K‐0002 011‐K‐0003
BUS A ‐ 011‐MK‐0002 A ‐
BUS B 011‐MK‐0001 011‐MK‐0002 B/C 011‐MK‐0003
o
(B/F) Start spare motors in case of partial failure of Bus A or B. (B) Verify that spare pump, air cooler, fan and compressor are in operation. (B) Monitor pressure / temperature profile of the unit, in order to detect any upset. (B/F) Verify that the furnaces are operative, if they are not; proceed to restart following 011‐IP‐ 0007 / 0008 stage 200.
When momentary power loss occur, pumps and fan motor of air cooler of unit except G‐0025 (Closed drain pump), G‐0027 (Amine closed drain pump), G‐0028 (LPC pump) and A‐0008 ( Flash vapor condenser), are designed by reacceleration program. The equipment excluded can be started manually after passing of the critical time.
UNIT STATUS With total power failure all machinery stops and the respective interlock activated. The plant is in shutdown and the sections are isolated one from each other.
FOLLOW UP ACTIONS If the incident could be mitigated monitoring of the main process variables in order to detect any upset. In case of the contingence cannot be mitigated a in a short‐time, CDU/VDU unit will be shut‐down.
ISOLATE No isolation is required.
POST INCIDENT PLAN After the power is recovered, an evaluation of the consequences shall be done in order to define furthers steps. After confirming that the unit is safe and the operation is guaranteed, and the maintenance procedures have been carried out (if it is necessary) the unit could be restarted. Proceed as in the normal start‐up case according to 011‐IP‐0002 stage 500.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 45.
LOSS OF COOLING WATER Document Number
Description
SA-JER-DS011-TRJR-400015
LOSS OF COOLING WATER
Rev. 01
ORIGINAL SIGNED IN PROJECT FILE
INCIDENT STRATEGY FOR:
LOSS OF COOLING WATER UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0029 Date: 28‐NOV‐2011 Rev. : 01 Pag. : 1 of 3
DOCUMENT: SA‐JER‐DS011‐TRJR‐400015
INCIDENT STRATEGY FOR:
LOSS OF COOLING WATER UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Note: This document does not replace the corresponding “Emergency Card” which will be developed by SATORP. REVISION CONTROL REV. 01 0
DATE 28‐NOV‐2011 07‐JUL‐2011
DESCRIPTION APPROVED FOR CONSTRUCTION ISSUE FOR REVIEW
PREPARED BY
CHECKED BY
APPROVED BY
Tulio Hernández
Miguel Ángel Castro
Juan Lechuga
DISCIPLINE CODE PRO Document Class: 2
DOCUMENT TYPE MAN
UNIT 011
SYSTEM
Legend
o ◊
Action Verification Safety Action
B – Board Operator F – Field Operator S – Shift Supervisor
INCIDENT STRATEGY FOR:
LOSS OF COOLING WATER UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0029 Date: 28‐NOV‐2011 Rev. : 01 Pag. : 2 of 3
IDENTIFICATION INDICATION o
(B) Low pressure at cooling water supply battery limit detected by PAL‐0272.
CONFIRMATION The following verification could be used as confirmation of the event: o (F) Low pressure read in PI‐0273. o (B) Low flow read in FI‐0095.
IMMEDIATE ACTIONS Note: The lost of cooling water stops the condensation in the exchangers of the vacuum package resulting in lost of vacuum in the column C‐0003, therefore the gas exceed can produce over pressure in column. However, PZV‐0019/20 (located on overhead column) sizing design includes this contingence.
(B/F) Communicate with cooling water supply Boardman to detect the incidence source. (F) Isolate the steam to ejector and close the cooling water to condenser. (B) Notify all the process units (HP HDS, DHC/MHC and DCU) about the emergency, communicate that the rundown products can be sent at high temperature. (B) Communicate with Waste Water Treated (WWT) operator to inform that brine could be sent at high temperature. (B) Reduce the unit charge at turndown capacity. (B/F) If cooling water is recovered in the next 10 minutes after the fault and once that utility department confirm and communicated to CDU/VDU Boardman that the cooling water is available, proceed to check the cooling water supply pressure (i.e. check that the pathway through the Instrument air system is open). (B) Re‐establish vacuum condition on column C‐0003, as soon as possible to minimize products off‐spec to slop. Open CW supply to condensers and after that open steam to ejectors. (B) Check the rundown temperatures. (B) In case of incident can be mitigated increase slowly unit capacity and adjust conditions to recover the unit as it was at the beginning of the incident.
In case that the loss total of cooling water contingence could not be mitigated immediately, take following action: (B) Reduce the unit capacity at turndown and implement VDU bypass procedure following 011‐ IP‐0022 (Vacuum unit By‐pass). Note: If VDU by‐pass procedure is not possible, then proceed with unit shutdown. See intermediate procedure CDU/VDU Shut down 011‐IP‐0003.
INCIDENT STRATEGY FOR:
LOSS OF COOLING WATER UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0029 Date: 28‐NOV‐2011 Rev. : 01 Pag. : 3 of 3
In case of VDU unit bypass operation, the following action will be taken: o (B) Verify that the two motors (A/B) on air cooler A‐0006 are running (running indicators MXL‐ 0006A and MXL‐0006B), to maximize the cooling in the flow of brine to WWT. o (B) Advised that rundown temperatures could be higher than normal, depending on the air coolers capacity, verify that all motors of air coolers are running: A‐0003; LAGO product (MXL‐0003A and MXL‐0003B). A‐0004; HAGO Product (MXL‐0004A and MXL‐0004B). (B) Check all products temperatures, after that unit works at reducing capacity: Kerosene to storage (TT‐0462), normal operation temperature 43 ºC. LAGO to storage and LP HDS (TT‐0323), normal operation temperature 50 ºC. HAGO to storage and HP HDS (TT‐0325), normal operation temperature 50 ºC. o (B) Storage tanks temperature shall be monitored by off‐site department during this upset. A peak of temperature can be handling due to liquid inventories inside the tanks.
UNIT STATUS If the contingence could be mitigated in a short time following the action in the previous step, the unit capacity is recover the unit as it was at the beginning of the incidence. If the contingence cannot be mitigated in a short‐time, the VDU is by‐passed and the unit is at turndown capacity. If VDU could not be bypassed the unit is at general shutdown.
FOLLOW UP ACTIONS Monitoring of the main process variables in order to maintain the unit performance.
ISOLATE If this contingency can mitigate in a short period, isolation is not required. If this VDU by‐pass is done, this unit is isolated.
POST INCIDENT PLAN If the unit is operated at reduced capacity, once the cooling water flow is re‐established the unit capacity could be recovered and VDU unit re‐start.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 46.
SHUTDOWN WITH LARGE RECIRCULATION Document Number
Description
SA-JER-DS011-TRJR-400016
SHUTDOWN WITH LARGE RECIRCULATION
Rev. 01
INCIDENT STRATEGY FOR:
SHUTDOWN WITH LARGE RECIRCULATION UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0030 Date: 30‐NOV‐2011 Rev. : 01 Pag. : 1 of 4
DOCUMENT: SA‐JER‐DS011‐TRJR‐400016
INCIDENT STRATEGY FOR:
SHUTDOWN WITH LARGE RECIRCULATION UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Note: This document does not replace the corresponding “Emergency Card” which will be developed by SATORP. REVISION CONTROL REV. 01 0
DATE 30‐NOV‐2011 22‐Jul‐2011
DESCRIPTION APPROVED FOR CONSTRUCTION ISSUE FOR REVIEW
PREPARED BY
CHECKED BY
APPROVED BY
Tulio Hernández
Miguel A. Castro
Juan Lechuga
DISCIPLINE CODE PRO Document Class: 2
DOCUMENT TYPE MAN
UNIT 011
SYSTEM
Legend
Action o Verification ◊ Safety Action
B – Board Operator F – Field Operator S – Shift Supervisor
INCIDENT STRATEGY FOR:
SHUTDOWN WITH LARGE RECIRCULATION UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0030 Date: 30‐NOV‐2011 Rev. : 01 Pag. : 2 of 4
IDENTIFICATION
INDICATION Note: This scenario considers at CDU/VDU shutdown of the unit while is operating at 50% of the normal flow rate and all products are mixing into the Slop header being cooled in E‐0037 and sending to the Slop&CDU long recirculation line. The outlet temperature in the furnace F‐0001 is 300 ºC
o o o o o o o
(B) Low flow at Crude Charge from G‐0001A/B, detected by FALL‐0002B. (B) Low flow at Desalted Crude from G‐0002A/B, detected by FALL‐0061B. (B) Low flow at Topped Crude from G‐0004A/B, detected by FALL‐0008B. (B) Low flow at Atmospheric Residue from G‐0014A/B, detected by FALL‐0032B. (B) Low flow at Vacuum residue to storage detected by FC‐0053. (B) In case of any pumps G‐0001, G‐0002, G‐0004, G‐0014 and G‐0018 associated with the crude long recirculation have a motor fault, DCS alarm are activated. (B) Low pressure at suction crude inlet line, detected by PALL‐0001, if the circulation is stopped by failure of the 661‐G‐1001A/B pumps in crude oil tanks.
CONFIRMATION o
o o
(B) Confirm that there is no/low crude feed flow detected by 011‐FC‐0001 (crude feed), 011‐FC‐ 0061A (desalted crude), FC‐0008A (Preflash bottom), FC‐0032A (Atmospheric residue), and FC‐ 0053 (at Vacuum residue to storage). (F) Confirm that there is low pressure in the suction line of 011‐G‐0001A/B, by PT‐0001, if the circulation is stopped by failure of the 661‐G‐1001A/B pumps in crude oil tanks. (F) Confirm that any pumps G‐0001, G‐0002, G‐0004, G‐00014 and G‐00018, is stopped.
IMMEDIATE ACTIONS
(B) Notify to the shift supervisor about this incident.
(B) Notify to all process units involves in the crude circulation during this contingency.
(B/F) Evaluate the severity of this contingency. In order to recover the operation status of the unit, as soon as possible:
(F/B) Try to re‐start any pumps G‐0001, G‐0002, G‐0004, G‐0014 and G‐0018 associated with the crude long recirculation or start its spare pumps for restart circulation.
(F/B) Check the circulation flow rate is stable through the unit to/from crude tank. Ensure that the flow rates for pumps G‐0001, G‐0002, G‐0004, G‐0014 and G‐0018 are operated under the minimum continuous flow. ‐ Open FV‐0002 and setting the flow rate through FC‐0002 at 528 T/h.
INCIDENT STRATEGY FOR:
SHUTDOWN WITH LARGE RECIRCULATION UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0030 Date: 30‐NOV‐2011 Rev. : 01 Pag. : 3 of 4
‐ Open FV‐0061 and setting the flow rate through FC‐0061 at 665 T/h ‐ Open FV‐0008 and setting the flow rate through FC‐0008 at 474 T/h. ‐ Open FV‐0032 and setting the flow rate through FC‐0032 at 240 T/h. ‐ Open FV‐0063 and its bypass in case it is necessary to maintain 132 T/h.
(B) Evaluate the necessity of reduce the feedstock rate during this incident to 40 % of the normal flow rate. o (B) Check the flow rate through F‐0001 and F‐0002 passes. o (B) Re‐start the furnace F‐0001 and F‐0002, in case of they are tripped by low‐low crude flow rate (partial shutdown). o (B) Add burner and increase the crude heater F‐0001 outlet temperature to 300 ºC, adjusting TC‐0097AA, and 0097BB set point to 300 ºC. o (B) Check and monitor the liquid level of the bottoms C‐0001, C‐0002 and C‐0003 are stabilized and the long circulation is being stable. o (B) Check the temperatures at the bottoms C‐0001, C‐0002 and C‐0003. o (F/B) Verify the temperature of the product mixture at E‐00037 A‐D outlet is lower than 60 ºC by means TT‐0550.
(B) Once the plant stabilizes, increase slowly if needed the crude feed flow rate at the value that was working at the beginning of the incidence by adjusted in the flow set point of flow controller 011‐FC‐0006 at pre flash column inlet. In case any pumps G‐0001, G‐0002, G‐0004, G‐0014 and G‐0018 associated with the crude long recirculation and its spare cannot be re‐started quickly, then, proceed with the unit normal shutdown. If the large circulation is stopped by failure of the 661‐G‐1001A/B pumps in crude oil tanks (external failure), then: o (B) Stop the main fuel gas for furnaces F‐0001 and F‐0002 (partial shutdown).
(F/B) Proceed to establish the internal recirculation in the CDU/VDU through G‐0002, G‐0014, and G‐0018 at 150 ºC maximum. In case of the large circulating cannot re‐start before 12 hours, evaluate to proceed with the normal unit shutdown.
UNIT STATUS If the contingence could be mitigated in a short time following the action in the previous step, large circulation can be recovered as it was working at the beginning of the incidence. If the contingence cannot be mitigated in a short‐time, the internal recirculation line in CDU/VDU can be established. Otherwise, the unit shall be shutdown.
INCIDENT STRATEGY FOR:
SHUTDOWN WITH LARGE RECIRCULATION UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
FOLLOW UP ACTIONS Monitories the main process variables in order to maintain the large circulation.
ISOLATE If the contingency can mitigate in a short period, isolation is not required.
POST INCIDENT PLAN After the large circulation is available, proceed with the large recirculation at CDU/VDU.
Procedure No. 011‐IP‐0030 Date: 30‐NOV‐2011 Rev. : 01 Pag. : 4 of 4
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 47.
LOSS OF LGO PA Document Number
Description
SA-JER-DS011-TRJR-400017
LOSS OF LGO PA
Rev. 01
ORIGINAL SIGNED IN PROJECT FILE
Procedure No. 011‐IP‐0037 Date: 16‐NOV‐2011 Rev. : 01 Pag. : 1 of 4
INCIDENT STRATEGY FOR:
LOSS OF LAGO PA UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1 DOCUMENT: SA‐JER‐DS011‐TRJR‐400017
INCIDENT STRATEGY FOR:
LOSS OF LAGO PA UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Note: This document does not replace the corresponding “Emergency Card” which will be developed by SATORP. REVISION CONTROL REV. 01 0
DATE 16‐NOV‐2011 19‐JUL‐2011
DESCRIPTION APPROVED FOR CONSTRUCTION ISSUE FOR REVIEW
PREPARED BY
CHECKED BY
APPROVED BY
Tulio Hernández
Miguel Ángel Castro
Juan Lechuga
DISCIPLINE CODE PRO Document Class: 2
DOCUMENT TYPE MAN
UNIT 011
SYSTEM
Legend
o ◊
Action Verification Safety Action
B – Board Operator F – Field Operator S – Shift Supervisor
INCIDENT STRATEGY FOR:
LOSS OF LAGO PA UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0037 Date: 16‐NOV‐2011 Rev. : 01 Pag. : 2 of 4
IDENTIFICATION
INDICATION Note: The development of this strategy considers the cause of the incident the LAGO pump around pump failure. o o
(B) Motor fault and DCS alarm is activated, MXS‐G‐0010AB or MXS‐G‐0010BB. (B) High temperature at C‐0002 overhead, detected by TAH‐0245.
CONFIRMATION o o o o
(B) Low flow at LAGO PA, LAGO to C‐0002, detected by FC‐0023. (B) Low flow at LAGO pump back to C‐0002, detected by FC‐0024. (F) Confirm that there is low discharge pressure 011‐G‐0010 A/B, by PI‐0059 or PI‐0060. (F) Confirm that the LAGO pumps, 011‐G‐0010 A or G‐0010 B, is stopped.
IMMEDIATE ACTIONS Note: The objective of this procedure is minimize the upset operation in the atmospheric column C‐ 0002, cause for the loss of LAGO pump around.
(B) Notify all the process units (NHDT, LP HDS, and HP HDS) about the emergency. (B) Reduce the unit charge at turndown capacity. (B) Increase the HAGO PA at flow maximum as possible. (B) Increase draw‐off of KERO, LAGO and HAGO. (B) Maximize the KERO reflux and KERO PA should increase to reduce the column top temp. (B) Reduce the stripping steam to C‐0002. (B) Slightly decrease the outlet temperature in the crude heater F‐0001. (B/F) Route the products Kerosene, LAGO, HAGO to slop if necessary. Due to LAGO pump around is lost; the yield of atmospheric column products is affected for the increase of operating temperature.
In order to recover the operation status of the unit, as soon as possible: (F/B) Try to re‐start the LAGO pumparoud pumps 011‐G‐0010 A or start the spare pumps 011‐ G‐0010B. (B) Notify to NHDT unit the possible re‐establishment of LAGO PA from CDU unit. Once the LAGO pumparound pumps G‐0010 A/B are operating the following check shall be done: (B) Check that normal operating temperature on top column C‐0002 is recovered (TI‐0245) (normal temperature 119 ºC). (B) Check the gas temperature of column entering to tray # 29 by means TI‐0107 (normal operation temperature 278 ºC). (B) Check the gas temperature of column entering to tray # 34 by means TI‐0105 (normal operation temperature 230 ºC).
INCIDENT STRATEGY FOR:
LOSS OF LAGO PA UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0037 Date: 16‐NOV‐2011 Rev. : 01 Pag. : 3 of 4
o
(B) Check that normal operating temperature on top column C‐0001 is recovered (TI‐0058), (normal temperature 137 ºC). (B) Adjust set point of FC‐0023 (LAGO pump around) at 420 T/h. (B) Adjust set point of FC‐0024 (LAGO reflux pump back) at 117 T/h. (B) Verify liquid level in chimney tray 30 of LAGO during this operation (tray # 30) (LT‐0013). (B) Verify that level controller LC‐0013 is in cascade mode and adjust set point at 50%. (B) Verify the profile of temperature in the column C‐0001 and C‐0002. (B) Verify all chimney trays of column C‐0002: Tray # 15 by mean LI‐0018 Tray # 44 by mean LI‐0012 (B) Verify and monitor the liquid level of the C‐0001 column bottoms by means of LI‐0001. (B) Verify and monitor the liquid level of the C‐0002 column bottoms by means of LI‐0124. (B) Once the plant stabilizes, increase slowly the feed at the value that was working at the beginning of the incidence. (B) Adjust the Kerosene, LAGO and HGO pump around flows and tune‐in to establish the normal expected temperature profile in the columns. Observe that the temperature profile through the preheating exchanger train downstream desalter is correct in accordance with the heat & material balance. (B/F) Check that the products are yields stable and accordance with their qualities specification. (F) Route the product to normal destination.
In case of a LAGO pumps cannot be re‐started immediately, then: (B) Mantain the unit at turndown capacity. (F/B) Try to increase the Kerosene pumparoud flow rate by increasing the Kero PA Duty, adjusting the 011‐FC‐0003. (F/B) Try to increase the HAGO pumparoud flow rate by increasing the HAGO PA Duty, adjusting the 011‐FC‐0013. (F/B) Try to reduce the outlet temperature in the Crude Heater F‐0001, by adjusting the 011‐ TC‐0097AA, y 0097BB set point to 360 ºC. (F/B) Check the profile of temperature in the column C‐0002. (F) If necessary inject flushing oil through LAGO pumparound located downstream 011‐FV‐0023 (line 4”‐FLO‐011018302), in order to re‐establish the liquid in the top and help to cool the overhead section. (B/F) Confirm the quality of rundown products.
UNIT STATUS If the contingence could be mitigated in a short time following the action in the previous step, the unit capacity is recovered as it was working at the beginning of the incidence. If the contingence cannot be mitigated in a short‐time, the CDU/VDU unit can be operated at reduced feed crude rate with a minor furnace coil outlet temperature.
FOLLOW UP ACTIONS Monitoring of the main process variables in order to maintain the unit performance.
INCIDENT STRATEGY FOR:
LOSS OF LAGO PA UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0037 Date: 16‐NOV‐2011 Rev. : 01 Pag. : 4 of 4
ISOLATE Not required.
POST INCIDENT PLAN After the LAGO pumparound is available, re‐start the pumps, and adjust normal capacity and the operational conditions.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 48.
LOSS OF HGO PA Document Number
Description
SA-JER-DS011-TRJR-400018
LOSS OF HGO PA
Rev. 01
ORIGINAL SIGNED IN PROJECT FILE
Procedure No. 011‐IP‐0038 Date: 16‐NOV‐2011 Rev. : 01 Pag. : 1 of 4
INCIDENT STRATEGY FOR:
LOSS OF HAGO PA UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1 DOCUMENT: SA‐JER‐DS011‐TRJR‐400018
INCIDENT STRATEGY FOR:
LOSS OF HAGO PA UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Note: This document does not replace the corresponding “Emergency Card” which will be developed by SATORP. REVISION CONTROL REV. 01 00
DATE 16‐NOV‐2011 20‐JUL‐2011
DESCRIPTION APPROVED FOR CONSTRUCTION ISSUE FOR REVIEW
PREPARED BY
CHECKED BY
APPROVED BY
Tulio Hernández
Miguel Ángel Castro
Juan Lechuga
DISCIPLINE CODE PRO Document Class: 2
DOCUMENT TYPE MAN
UNIT 011
SYSTEM
Legend
o ◊
Action Verification Safety Action
B – Board Operator F – Field Operator S – Shift Supervisor
INCIDENT STRATEGY FOR:
LOSS OF HAGO PA UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0038 Date: 16‐NOV‐2011 Rev. : 01 Pag. : 2 of 4
IDENTIFICATION
INDICATION Note: The development of this strategy considers the cause of the incident the HAGO pump around pump failure. o o
(B) Motor fault and DCS alarm is activated, MXS‐G‐0012AB or MXS‐G‐0012BB. (B) High temperature at C‐0002 overhead, detected by TAH‐0245.
CONFIRMATION o o o o
(B) Low flow at HAGO PA, HAGO to C‐0002, detected by FC‐0013. (B) Low flow at HAGO pump back to C‐0002, detected by FC‐0022. (F) Confirm that there is low discharge pressure 011‐G‐0012 A/B, by PI‐0061 or PI‐0062. (F) Confirm that the HAGO pumps, 011‐G‐0012 A or G‐0012 B, is stopped.
IMMEDIATE ACTIONS Note: The objective of this procedure is minimize the upset operation in the Atmospheric Column C‐ 0002, cause for the loss of HAGO pump around.
o
(B) Notify all the process units (NHDT, LP HDS, and HP HDS) about this incident. (B) Reduce the unit charge at turndown capacity. (B) Decrease the outlet temperature in the crude heater F‐0001. (B) Increase the LAGO PA, LAGO REFLUX, KERO PA and KERO REFLUX. (B/F) Route the products Kerosene, LAGO, HAGO to slop if necessary, due to HAGO pump around is lost, the yield and qualities of Atmospheric Column products is affected for the increase of operating temperature. (F) If the column pressure increase open the bypass of PSZV to flare to maintain column pressure and reduce the stripping steam.
In order to recover the operation status of the unit, as soon as possible: (F/B) Try to re‐start the HAGO pumparound pumps 011‐G‐0012 A or start the spare pumps 011‐ G‐0012B. (B) Notify to NHDT unit the possible re‐establishment of HAGO PA from CDU unit. Once the HAGO pumparound pumps G‐0012 A/B are operating the following check shall be done: (B) Check that normal operating temperature on top column C‐0002 is recovered (TI‐0245), (normal temperature 119 ºC). (B) Check the vapour temperature of column entering to tray # 14 by means TI‐0110 (normal operation temperature 328 ºC). (B) Check the vapour temperature of column entering to tray # 19 by means TI‐0108 (normal operation temperature 294 ºC). (B) Check that normal operating temperature on top column C‐0001 is recovered (TI‐0058), (normal temperature 137 ºC).
INCIDENT STRATEGY FOR:
LOSS OF HAGO PA UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0038 Date: 16‐NOV‐2011 Rev. : 01 Pag. : 3 of 4
o
(B) Adjust set point of the HAGO pump around return through FV‐0013 control valve at 400 T/h. (B) Adjust set point of HAGO reflux pump back to the column C‐0002, through FV‐0022 at 137 T/h. (B) Verify liquid level in chimney tray of HAGO during this operation (tray # 15) (LT‐0018 or LT‐ 0016). (B) Verify that level controller LC‐0016 is in cascade mode and adjust set point at 50%. (B) Verify liquid level for chimney trays of column C‐0002: Tray # 30 by mean LI‐0015 or LT‐0013 (LAGO draw‐off) Tray # 44 by mean LI‐0012 or LT‐0010 (KERO draw‐off) (B) Verify and monitor the liquid level of the C‐0001 column bottoms by means of LI‐0001. (B) Verify and monitor the liquid level of the C‐0002 column bottoms by means of LI‐0124. (B) Once the plant stabilizes and HAGO PA is reestablished, increase slowly the feed at the value that was working at the beginning of the incidence. (B) Adjust the Kerosene, LAGO and HAGO pump around flows and tune‐in to establish the normal expected temperature profile in the columns. (F) Check that the products are yields stable and accordance with their qualities specification, especially Kerosene (flash point by mean of analyzer AT‐0011, flash point must be >=38ºC). (F) Route the product to normal destination.
In case of a HAGO pumps cannot be re‐started immediately, then:
Note: If the HAGO pumparound can not reestablished, the NHDT unit has HP steam reboiler 111‐E‐ 0008 can supply 50% of the max operating duty.
(B) Maintain the unit at turndown capacity. (F/B) Try to increase the Kerosene pumparoud flow rate by increasing the Kero PA Duty, adjusting the 011‐FC‐0003. (F/B) Try to increase the LAGO pumparoud flow rate by increasing the LAGO PA Duty, adjusting the 011‐FC‐0023. (F/B) Try to reduce the outlet temperature in the Crude Heater F‐0001, adjust 011‐TC‐0097AA, and TC‐ 0097BB set point to 360 ºC (vs normal value 366 ºC). (F/B) Check the profile of temperature in the column C‐0002. (B/F) Confirm the quality of rundown products.
UNIT STATUS If the contingence could be mitigated in a short time following the action in the previous step, the unit capacity is recovered as it was working at the beginning of the incidence. If the contingence cannot be mitigated in a short‐time, the CDU/VDU unit can be operated at reduced feed crude rate with a minor furnace coil outlet temperature.
FOLLOW UP ACTIONS Monitoring of the main process variables in order to maintain the unit performance.
ISOLATE Not required.
INCIDENT STRATEGY FOR:
LOSS OF HAGO PA UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0038 Date: 16‐NOV‐2011 Rev. : 01 Pag. : 4 of 4
POST INCIDENT PLAN After the HAGO pumparound is available, re‐start the pumps, and adjust normal capacity and the operational conditions.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 49. LOSS OF TEMPERED WATER Document Number
Description
SA-JER-DS011-TRJR-400019
LOSS OF TEMPERED WATER
Rev. 01
ORIGINAL SIGNED IN PROJECT FILE Procedure No. 011-IP-0041
INCIDENT STRATEGY FOR:
LOSS OF TEMPERED WATER UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Date: 18-Oct-2011 Rev. : 01 Pag. : 1 of 4
DOCUMENT: SA-JER-DS011-TRJR-400019
INCIDENT STRATEGY FOR:
LOSS OF TEMPERED WATER UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Note: This document does not replace the corresponding “Emergency Card” which will be developed by SATORP.
REVISION CONTROL REV. 00 01
DATE 19-Jul-2011 18-Oct-2011
DESCRIPTION ISSUE FOR REVIEW APPROVED FOR CONSTRUCTION
PREPARED BY
CHECKED BY
APPROVED BY
Miguel A. Castro
José Luis Roldan
Juan Lechuga
DISCIPLINE CODE PRO Document Class: 2
Legend
Action o Verification ◊ Safety Action
DOCUMENT TYPE MAN
UNIT 011
SYSTEM
B – Board Operator F – Field Operator S – Shift Supervisor
INCIDENT STRATEGY FOR:
LOSS OF TEMPERED WATER UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011-IP-0041 Date: 18-Oct-2011 Rev. : 01 Pag. : 2 of 4
IDENTIFICATION INDICATION Note: - The development of this strategy considers as worst scenario to loss of Tempered Water the Tempered Water pump failure. The scenario of the failure of the Air Cooler (A-0007) is less conservative and considers as a long term scenario. o o
(B) Motor fault and DCS alarm is activated, MXS-G-0022AB or MXS-G-0022BB. (B) Low flow of tempered water system detected by FAL-0073B.
CONFIRMATION o o o
(F) Confirm that the Tempered water pumps, 011-G-0022 A or G-0022 B, is stopped. (B) Confirm that there is no/low Tempered Water flow detected by 011-FT-0073A. (F) Confirm that there is low discharge pressure 011-G-0022A/B, by PI-0151 or PI-0152.
IMMEDIATE ACTIONS (B) Inform to the Offsite unit increase the temperature high in HVGO. (B) Notify to DHC/MHC units about the emergency. (B) Evaluate the necessity of reduce the feedstock rate until during this incident through FC0006. (B) Evaluate the necessity of route all VGO product to the DHC/MHC. In order to recover the operation status of the unit, as soon as possible: o o o o
(F/B) Try to re-start the tempered water pumps 011-G-0022A or Start the pumps 011-G-0022B. (F) Verify discharge pressure around 5.8 barg on PI-0151 and PI-0152. (F) Verify stable pump operation checking main operational parameters. (B) Put in auto control TC-0230 and set as its normal operating set point, 65ºC. (F) Monitor temperature, TI-0229, to a value of 65ºC. (F) Keep Tempered Water System in circulation.
Note: Under normal conditions required make-up will be minimum (only evaporating losses or leaks must be compensated). (B/F) Check the temperature of the HVGO product going to storage, by TT-0202, normal temperature 90 ºC and verify that TC-0173 is setting at its normal operating set point, 90 ºC.
INCIDENT STRATEGY FOR:
LOSS OF TEMPERED WATER UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011-IP-0041 Date: 18-Oct-2011 Rev. : 01 Pag. : 3 of 4
Note: If the all HVGO product is going to storage and an upset operational of TPW system occurs (5 min.), the estimated average temperature in the tank (assuming an inventory of 10% of volume in the tank as HVGO at 90 ºC) and its receiving a batch of aprox. 28 m3 of HVGO at 160 ºC, resulted in a rise of temperature of 2 ºC, and does not exceed the design temperature in tanks (118 ºC). o
(F) Verify temperature the TW outlet to E-0030, by TI-0172, is around to its normal value 85ºC.
Note: Periodical monitoring of water quality shall be done via sample connection SC-0063 (type 7) and according to CDU/VDU analytical schedule.
(B) Once the plant stabilizes, increase slowly the feedstock flowrate at the value that was working at the beginning of the incidence by adjusted in the flow set point of flow controller FC0006 at pre flash column inlet.
If the tempered water pumps 011-G-0022 pump cannot be re-started immediately, then: (F/B) Decrease the crude feed flow rate gradually by means of FC-0006, to reduce the HVGO production going to storage and avoiding high temperature of the HVGO rundown to storage (TI-0202). If necessary maximize the HVGO to DHC/MHC unit. (F/B) In case of DHC/MHC unit needs to reduce the HVGO feeding then reduces the unit at turndown and implemented the VDU by-pass mode. Note that the Atmospheric Residue shall be going to the Delayed Coker Unit. Note: During this operation, Atmospheric Residue shall not be going to the Blender and then proceed with the unit shutdown due to TPW system is not available. Refer to the intermediate procedure CDU/VDU shutdown IP-0003.
UNIT STATUS If the contingence could be mitigated in a short time following the action in the previous step, the TPW systems and the unit capacity is recovered to that as it was working at the beginning of the incidence. If the contingence cannot be mitigated in a short-time, the VDU is by-passed and the unit is at turndown capacity. If VDU could not be bypassed the unit is at general shutdown.
FOLLOW UP ACTIONS No special actions are required. Monitoring of the main process variable in order to maintain the unit performance a paid special attention to the HVGO rundown temperature to storage.
INCIDENT STRATEGY FOR:
LOSS OF TEMPERED WATER UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011-IP-0041 Date: 18-Oct-2011 Rev. : 01 Pag. : 4 of 4
ISOLATE If the contingency can mitigate in a short period, isolation is not required. If the VDU by-pass is done, this VDU unit is isolated.
POST INCIDENT PLAN After the tempered water pumps and system is available, re-start the VDU unit, in case the VDU is bypassed.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 50.
LOSS OF BFW Document Number
Description
SA-JER-DS011-TRJR-400020
LOSS OF BFW
Rev. 01
ORIGINAL SIGNED IN PROJECT FILE
Procedure No. 011‐IP‐0042 Date: 21‐NOV‐2011 Rev. : 01 Pag. : 1 of 4
INCIDENT STRATEGY FOR:
LOSS OF BFW UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1 DOCUMENT: SA‐JER‐DS011‐TRJR‐400020
INCIDENT STRATEGY FOR:
LOSS OF BFW UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Note: This document does not replace the corresponding “Emergency Card” which will be developed by SATORP. REVISION CONTROL REV. 01 0
DATE 21‐NOV‐2011 12‐JUL‐2011
DESCRIPTION APPROVED FOR CONSTRUCTION ISSUE FOR REVIEW
PREPARED BY
CHECKED BY
APPROVED BY
Tulio Hernández
Miguel Ángel Castro
Juan Lechuga
DISCIPLINE CODE PRO Document Class: 2
DOCUMENT TYPE MAN
UNIT 011
SYSTEM
Legend
o ◊
Action Verification Safety Action
B – Board Operator F – Field Operator S – Shift Supervisor
INCIDENT STRATEGY FOR:
LOSS OF BFW UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0042 Date: 21‐NOV‐2011 Rev. : 01 Pag. : 2 of 4
IDENTIFICATION INDICATION o
(B) Low pressure at BFW supply battery limit detected by PAL‐0377.
CONFIRMATION The following verification could be used as confirmation of the event: o (F) Low pressure read in PI‐0270 (located on BL). o (B) Low flow read in FI‐0094 (Located on BL). o (B) PV‐0417 A/B opening will fully open. o (B) Low liquid level on D‐0011 (steam drum) with LAL‐0065. LV‐0065 opening will fully open. o (B) High temperature downstream desuperheater DS‐0001 (TI‐0360). TV‐0043 opening will increase. o (B) High temperature downstream desuperheater DS‐0002 (TI‐0181). TV‐0049 opening will increase. o (B) High temperature downstream desuperheater DS‐0003 (TI‐0233) in case of MPS temperature inlet to unit is 320 ºC. TV‐0233 opening will increase. o (B) Low liquid level on D‐0007 (Desalting water drum) with LAL‐0069 in case of water supply is being phenolic or non‐phenolic plus BFW. FV‐0059A opening will fully open. Note: For Unit 012, low liquid level on D‐0007 could occur in case of the BFW is being feeding to unit.
IMMEDIATE ACTIONS
(B / F) Try to mitigate the cause of the upset: ‐ Restore the boiler feed water supply (i.e. check that the pathway through the BFW system is open; communicate with boiler feed water supply operator to detect the incidence source). o (B) Verify that desuperheater downstream temperatures are in normal operation: ‐ DS‐0001 stripping steam from F‐0001 to column C‐0002, C‐0005 and C‐0006 (TT‐0043) at 350ºC. ‐ DS‐0002 stripping steam from F‐0002 to column C‐0003 (TT‐0049) at 350 ºC. ‐ DS‐0003 MP steam from BL (TT‐0233) at 270ºC. o (B) Verify the liquid level in D‐0010 (LI‐0108). o (B) Verify the liquid level in D‐0011 (LI‐0063). (B) Verify the liquid level in D‐0007 (LI‐0069). If the liquid level is decreasing, proceed to increase the set point of FC‐0059B (Non phenolic sour water from U‐212/213) or increase the set point of FC‐0171 (Phenolic SWS).
INCIDENT STRATEGY FOR:
LOSS OF BFW UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0042 Date: 21‐NOV‐2011 Rev. : 01 Pag. : 3 of 4
In case that the contingence could not be mitigated immediately: (B) Notify all the process units (NHDT, LP HDS, HP HDS, DHC/MHC and DCU) and utilities about the planned CDU/VDU reduce capacity. (B) Decrease the crude feed rate gradually by means of FC‐0006, to avoid high temperature of vacuum residue rundown to storage (TI‐0177). (B/F) Try to reduce the outlet temperature in the vacuum heater F‐0002, adjust TC‐0140AA, and TC‐0140BB, set point to 400 ºC. (B) If it is necessary reduces the temperature of bottom by reducing set point for TC‐0204. (F) If it necessary, try to manipulate the TC‐0057 by reducing the set point and close HC‐0008 by reducing its opening. (B) Notify to the Coker Unit if possible to take more vacuum residue flow for a temporary time that permit reduces the vacuum residue flow rate to the storage. (B) Reduce the stripping steam flow rates by adjusting the set of: Steam from DS‐0003: FC‐0007 for C‐0001. Steam from DS‐0001: FC‐0021 for C‐0002 FC‐0027 for C‐0005 FC‐0028 for C‐0006 Steam from DS‐0002: FC‐0056 for C‐0003. o (B) Verify the composition of following products: Kerosene: Flash point (AT‐0011) (FP >= 38 ºC). LAGO 95% ASTM D86 (AT‐0025), located downstream E‐0034. HAGO 95% ASTM D86 (AT‐0026), located downstream E‐0035). o (B) Verify that the stripping steam temperature to columns are in normal conditions operation: DS‐0001 downstream normal temperature will be controlled at 350 ºC by mean of TC‐0043. DS‐0002 downstream normal temperature will be controlled at 350 ºC by mean of TC‐0049. DS‐0003 downstream normal temperature will be controlled at 270 ºC by mean of TC‐0233. o (B) Assure that all vacuum production is aligning to DCU unit. o (B) Verify that liquid level on D‐0011 (LI‐0063) is not decreasing. o (B) Verify liquid level on D‐0010 (LI‐0108), in this case BFW is make‐up of losses in the tempered water system. o (B) Verify liquid level on D‐0007 (LI‐0069), when the desalting water system is feeding of non phenolic plus BFW (phenolic stripper sour water from SWS Unit 211 is not available). o (B) Verify all operating condition at low capacity.
UNIT STATUS If the contingence could be mitigated in a short time, the unit is recovered to that as it was working at the beginning of the incident. If the contingence cannot be mitigated in a short‐time, the unit is operating at low capacity.
INCIDENT STRATEGY FOR:
LOSS OF BFW UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0042 Date: 21‐NOV‐2011 Rev. : 01 Pag. : 4 of 4
FOLLOW UP ACTIONS In case of that the contingence could be mitigate, monitor the temperature profile of the unit and the level of the vessel D‐0007, D‐0010 and D‐0011 in order to detect any upset.
ISOLATE No isolation is required.
POST INCIDENT PLAN If the unit is operated at reduced capacity, once the BFW flow is re‐established the unit capacity could be recovered.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 51.
LOSS OF HVGO Document Number
Description
Rev.
SA-JER-DS011-TRJR-400021
LOSS OF HVGO
01
ORIGINAL SIGNED IN PROJECT FILE
INCIDENT STRATEGY FOR:
LOSS OF HVGO PRODUCT UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0045 Date: 22‐NOV‐2011 Rev. : 01 Pag. : 1 of 3
DOCUMENT: SA‐JER‐DS011‐TRJR‐400021
INCIDENT STRATEGY FOR:
LOSS OF HVGO PRODUCT UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Note: This document does not replace the corresponding “Emergency Card” which will be developed by SATORP. REVISION CONTROL REV. 01 0
DATE 22‐NOV‐2011 06‐Jul‐2011
DESCRIPTION APPROVED FOR CONSTRUCTION ISSUE FOR REVIEW
PREPARED BY
CHECKED BY
APPROVED BY
Tulio Hernandez
Miguel A. Castro
Juan Lechuga
DISCIPLINE CODE PRO Document Class: 2
DOCUMENT TYPE MAN
UNIT 011
SYSTEM
Legend
Action o Verification ◊ Safety Action
B – Board Operator F – Field Operator S – Shift Supervisor
INCIDENT STRATEGY FOR:
LOSS OF HVGO PRODUCT UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0045 Date: 22‐NOV‐2011 Rev. : 01 Pag. : 2 of 3
IDENTIFICATION
INDICATION Note: ‐The development of this strategy considers that the cause of this incident is HVGO product control valve failure (FV‐0049). For loss HVGO product due to HVGO pumparound pump failure refer to IP‐0052 (Loss of MVGO/HVGO PA). o
(B) High liquid level at HVGO draw‐off tray, detected by LAH‐0048.
CONFIRMATION o o
(B) Confirm that there is no/low HVGO product flow detected by 011‐FT‐0049. (F) Confirm that FV‐0049 is closed.
IMMEDIATE ACTIONS In order to recover the operation status of the unit, as soon as possible:
(F/B) When field operator confirms that FV‐0049 is closed, proceed to open the by‐pass line of the control valve FV‐0049, and adjust manually its opening to maintain the HVGO production, through the FT‐0049 at its normal flow rate.
(B) Notify to DHC/MHC and DCU units about this emergency and its impact downstream units.
(B) Evaluate the necessity of reduce the feedstock rate during this incident through FC‐0006.
(B) Evaluate the necessity of route product to slop.
(B) Check the liquid level in the HVGO draw‐off tray by LC‐0048. During the failure, the HVGO draw‐off tray will eventually overspill and certain flow of the HVGO will be run down with the vacuum residue.
(B) Reduce FC‐0012 HVGO pumparound flow from normal set point to help to reduce level at HVGO by recovered more HVGO portion at MVGO level.
(B) Check the profile of temperature in the column C‐0003.
(B) Check the vapour temperature entering to the wash oil section by means TT‐0327.
(B/F) Check the topped crude inlet temperature to the F‐0001.
(B/F) Check the desalted crude inlet temperature to the preflash column.
(B/F) Check the temperature of the MVGO product going to DHC and storage.
(B/F) Check the product to slop if necessary. Sample connections are available for MVGO, and Vacuum residue.
(B) Once the plant stabilizes, increase slowly it needed the throughput at the value that was working at the beginning of the incidence by adjusted in the flow set point of flow controller FC‐0006 at pre flash column inlet.
INCIDENT STRATEGY FOR:
LOSS OF HVGO PRODUCT UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0045 Date: 22‐NOV‐2011 Rev. : 01 Pag. : 3 of 3
o o o o
(B) Adjust the LVGO and HVGO pump around flows and tune‐in to establish the normal expected temperature profile in the columns. (B) Check that the temperature profile through the preheating exchanger train is in accordance with normal operating conditions. (F) Check that the products flows and yields are on qualities specification. (F) Route the product to normal destination if necessary.
UNIT STATUS If the contingence could be mitigated in a short time following the action in the previous step, the unit capacity is recovered to that as it was working at the beginning of the incidence.
FOLLOW UP ACTIONS No special actions are required. Normal monitoring of the unit performance.
ISOLATE If the contingency can mitigate in a short period isolation is not required.
POST INCIDENT PLAN After the stroke check for HVGO product control valve FV‐0049 have been done and is available, proceed to re‐commission the control valve FV‐0049.
DOCUMENT No.: SA-JER-DS011-TRJR-400100
REV: 01 Date: 16-MAY-2013
TR Project No.: 02020
ATTACHMENT 52.
LOSS OF DESALTER WATER Document Number
Description
SA-JER-DS011-TRJR-400022
LOSS OF DESALTER WATER
Rev. 01
ORIGINAL SIGNED IN PROJECT FILE
INCIDENT STRATEGY FOR:
LOSS OF DESALTER WATER UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0047 Date: 25‐nov‐2011 Rev. : 01 Pag. : 1 of 5
DOCUMENT: SA‐JER‐DS011‐TRJR‐400022
INCIDENT STRATEGY FOR:
LOSS OF DESALTER WATER UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Note: This document does not replace the corresponding “Emergency Card” which will be developed by SATORP. REVISION CONTROL REV. 01 0
DATE 25‐Nov‐2011 18‐Jul‐2011
DESCRIPTION APPROVED FOR CONSTRUCTION ISSUE FOR REVIEW
PREPARED BY
CHECKED BY
APPROVED BY
Tulio Hernandez
Miguel A. Castro
Juan Lechuga
DISCIPLINE CODE PRO Document Class: 2
DOCUMENT TYPE MAN
UNIT 011
SYSTEM
Legend
Action o Verification ◊ Safety Action
B – Board Operator F – Field Operator S – Shift Supervisor
INCIDENT STRATEGY FOR:
LOSS OF DESALTER WATER UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0047 Date: 25‐nov‐2011 Rev. : 01 Pag. : 2 of 5
IDENTIFICATION
INDICATION Note: The development of this strategy considers as worst scenario to loss of Desalter water the Desalting Water pump failure. The scenario of the failure of the Phenolic Stripped Sour water and Non Phenolic stripped water at the same time is less conservative due to BFW line is implemented as make‐ up. o (B) Motor fault and DCS alarm is activated, MXS‐G‐0021AB or MXS‐G‐0021BB. o (B) Low flow of desalting water coming from G‐0021, detected by FAL‐0180A.
CONFIRMATION o o o o
(B) Confirm that there is no/low desalting water flow detected by 011‐FC‐0005, and 011‐FC‐ 0004. (F) Confirm that there is low discharge pressure G‐0021A/B, by PI‐0096 or PI‐0097. (F) Confirm that the Desalting water pumps, G‐0021 A or G‐0021 B, is stopped. (B) Confirm that pressure in the desalters D‐0001 and D‐0002 is stable and not fluctuated. Desalters will operate a wash water injection rate of about 5‐8% the total crude rate. Operating at a very low wash water rate of 2% can lead to the creation of some very severe emulsions and will generally have very poor desalting efficiencies.
IMMEDIATE ACTIONS
(B) Notify to Phenolic and Non‐ Phenolic SWS units (Units 211 and 213 respectively) about this incident.
(B) Communicate with Waste Water Treatment unit (WWT) about this incident. In order to recover the operation status of the unit, as soon as possible:
(F/B) Check the oil/water interface level in the D‐0002. In case the liquid level is decreasing, proceed to put the LDC‐0092 controller in manual mode and reduces its opening to reduces G‐ 0024 A/B flow towards D‐0001 and maintain the interface in D‐0002. Continue to monitor the interface level using the try‐cocks.
(F) Check the G‐0024 A/B flow through the FT‐0142A. o (F) Verify that manual block valve in BL of Phenolic Stripped Sour water and Non Phenolic stripped water are open. o (F) Confirm that the pressure BL of Phenolic Stripped Sour water and Non Phenolic stripped water are at its normal conditions, by PI‐0164 and PI‐0447, respectively.
(F/B) Check the flow controller FC‐0171, FC‐0059B and FC‐0059A (Water feed to desalting water to surge drum D‐0007) are available at its normal conditions.
INCIDENT STRATEGY FOR:
LOSS OF DESALTER WATER UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0047 Date: 25‐nov‐2011 Rev. : 01 Pag. : 3 of 5
(F/B) Once the previous points are check, try to re‐start the desalting water pumps G‐0021A or Start the pumps G‐0021B.
(F/B) Adjust to 5‐8 % the ratio water/crude oil to D‐0001/D‐0002, increasing water flow with FC‐0005 and FC‐0060. Desalters D‐0001/D‐0002 are operated in series as two stage desalting unit.
(B) Verify and monitor the liquid level in the D‐0007 by means of LC‐0067 or LT‐0069. o (F/B) Check the oil/water interface level, LDC‐0089 and LDC‐0092, are at its normal conditions and not decreasing. Continue to monitor the interface level using the try‐cocks. Note: In case of low‐low interface oil/water in D‐0001, the transmitter LDT‐0090 in D‐0001 shut the ZV‐ 0110 avoid the potential carryover of the HC into the effluent brine, by means ZC‐0318. o (B) Check the Brine BL temperature to the WWT, by TT‐0185, normal operation temperature 42 ºC. If necessary maximize the cooling on air cooler A‐0006 (Brine Cooler). o (F) Check the quality of Brine to WWT assures that oil content does not exceed 150 ppm wt. o (B) Check the LAGO product temperature to the Storage and LP HDS, by TT‐00323, normal operation temperature 50 ºC. If necessary maximize the cooling on air cooler A‐0004 and verify that all motors of air coolers are running. o (F/B) Check the pH in the Sour Water coming from drums D‐0003, D‐0004 and D‐0006, and D‐ 0008. If necessary adjust the neutralization agent and corrosion inhibitor injections to columns C‐0001, C‐0002 and C‐0003. o (F/B) Check the previous results of pH in SW, through the following pH analyzers located in different point of CDU/VDU: ‐ In the sour water pipeline from Preflash Reflux Drum 011‐D‐0003 to the Sour Water Recovery Drum 011‐D‐0006.Tag. 011‐AT‐0021. ‐ In the sour water pipeline from CDU Reflux Drum D‐0004 to the Sour Water Recovery Drum 011‐D‐0006.Tag. 011‐AT‐0019. ‐ In the sour water pipeline from the Vacuum System Recovery Drum 011‐D‐0008. Tag. 011‐AT‐0017. ‐ In the sour water pipeline from Total Naphtha Drum 011‐D‐0005 to the Sour Water Recovery Drum 011‐D‐0006.Tag. 011‐AT‐0020. If the desalting water pumps 011‐G‐0021 pump cannot be re‐started immediately, then:
(F/B) Stop the desalted recirculation pumps 011‐G‐0024A/B to avoid that D‐0002 water/oil interface level continuously decreasing.
(F/B) Close desalter brine valve LDV‐0090 (desalter brine coming from 2nd desalter D‐0002).
(F/B) Close desalter brine valve LDV‐0089 (desalter brine coming from 1st desalter D‐0001).
(F/B) Close the valve ZV‐0110 and ZV‐0111.
(F/B) Close all the Wash Water BL assuming that the total wash water systems are not available.
(F) Take several samples on the feed to D‐0001 and the desalted crude oil from D‐0002 for analyses water and salt content. Note: Insufficient water injection results in a poor desalting. If the flow of Wash Water is eliminated for more than few days, solids will collect in the bottom of the process desalters, and may cover the effluent water outlet header and cause serious problems with the interface level control and water quality, etc.
(F/B) Adjust the injections of the neutralization agent and corrosion inhibitor to maximum rate.
INCIDENT STRATEGY FOR:
LOSS OF DESALTER WATER UNIT 011 – CRUDE DISTILLATION UNIT TRAIN 1
Procedure No. 011‐IP‐0047 Date: 25‐nov‐2011 Rev. : 01 Pag. : 4 of 5
Note: The main part of present chlorides in the crude oil of the CDU/VDU is eliminated with the appropriate operation of the desalters. Nevertheless, the excesses of chlorides in the inlet crude oil can cause severe corrosion in the Overhead system of the preflash and atmospheric columns. The control of the corrosion by hydrochloric acid in these systems can be reduced of the neutralization agent and corrosion inhibitor.
(F/B) Take several samples on the Sour Water accumulator of the Overhead system mainly on D‐0003 and D‐0004 and check the pH, Iron ions, chlorides, sulphide is useful to detect potential problems of corrosion. It is recommended that: ‐ The pH should be controlled between 5.5 and 6.5. ‐ The iron content in the water should be less than 2 ppm. This analysis should include also chlorine (
View more...
Comments
