Agila Owners Manual Jul06

TS1649-A-07.qxd

15/06/2006

07:10

Page 1

Owner’s Manual

AGILA

Operation, Safety and Maintenance

Reproduction or translation, in whole or in parts, is not permitted without prior written consent from Vauxhall Motors Ltd. All rights as understood under the copyright laws are explicitly reserved by Vauxhall Motors Ltd. All information, illustrations and specifications contained in this manual are based on the latest production information available at the time of publication. The right is reserved to make changes at any time without notice. Edition: July 2006.

TS 1525-A-07

AG I L A

©Copyright by Vauxhall Motors Ltd., England.

VAUXHALL Agila

Owner’s Manual

Data specific to your ve hicle Please enter your vehicle’s data here to keep it ea sily accessible. This information is available under the section "Technical da ta " as well as on the vehicle identifica tion plate and in the Service Book let.

Fuel Designati on

Engine oil Gra de Viscosity

Tyre pressure Tyre si ze

Tyre p ressure 3 p ersons

wi th full load

S ummer tyres

Front

Rear

Front

Rear

Winter tyres

Front

Rear

Front

Rear

Weights Permissible Gross Vehic le Weight –

EC k erbweight

=

Loading

Your Agila Dev eloped in accordance with the latest findings of vehicle research, it offers technical sophistication and exceptional comfort. Your vehicle represents an intelligent sy nthesis of adva nced technology, outstanding safety, environmental compatibility and economy in operation. It now lies with you to drive your vehicle safely and to see it performs perfectly. This O wner’ s M anual prov ides you with all the necessary information to that end. Make sure y our pa ssengers a re awa re of the possible risk of a ccident and injury which m ay result from improper use of the vehicle. The O wner’ s Ma nual should always be kept in the vehicle: rea dy to hand in the glove compartment.

Make use of the Owne r’s Manual:

z Its " In brief" section will give you an initial overv iew. z The table of contents a t the beginning of this owner’s ma nual and within the individual chapters w ill show y ou w here everything is. z Its index will help you find what y ou want. z It will familiarise y ou w ith the sop histicated technolog y. z It will increase your pleasure in y our vehicle. z It will help you to handle y our v ehicle ex pertly. The O wner’ s Ma nual is desig ned to be clearly laid-out and easily understood . This symb ol signifies: 6 Continue reading on next pag e. 3 The asterisk sig nifies: equipment not fitted to all v ehicles (m od el v aria nts, engine options, models specific to one country , optional eq uipm ent, Genuine Va ux ha ll Parts and Accessories).

9 Warnin g Text m arked 9 Warning provides information on risk of a ccident or injury . Disregard of the instruc tions may lead to injuries or endanger life. Inform your passengers accordingly. Yellow arrows in the illustrations serve as points of reference or ind icate some action to be performed. Black arrow s in the illustrations indicate a reaction or a second ac tion to be perform ed. Thank you for choosing a Vaux hall. We wish you ma ny hours of pleasurable driving. Your Va uxhall Team

Contents

Comm itment to c ustomer satisfaction: Our ai m: to k eep you happy with your vehicle. All Vauxhall Authorised Repairers offer first class service at competitive prices. Experienced, factory-trained technicians w ork according to factory instructions.Your Authorised Repairer can supply you with GEN UINE VAU XHALLAPPRO VED PARTS , which hav e und ergone stringent quality and precision chec ks, and of course useful and a ttrac tiv e VAUXHALL-APPROVED AC CESSO RIES. Our nam e i s your guara ntee! For d eta ils of the Va uxhall Authorised Rep airer Netw ork please r ing this number; 01582 - 427200

In Brief .. ..... .... ..... .... .... ..... .... ..... .... ..... .... .... . 2 Instrum ents ... ..... .... .... ..... .... ..... .... ..... .... .. 18 K eys, Doors, Bonnet .. ..... .... ..... .... ..... .... .. 28 S eats, Interior ..... .... .... ..... .... ..... .... ..... .... .. 39 S afety system s ... .... .... ..... .... ..... .... ..... .... .. 50 Lighting ..... .... ..... .... .... ..... .... ..... .... ..... .... .. 66 Windows, Sun roof .... ..... .... ..... .... ..... .... .. 69 C lim ate c ontrol .. .... .... ..... .... ..... .... ..... .... .. 72 Driving Hints . ..... .... .... ..... .... ..... .... ..... .... .. 82 S aving fuel, Protecting the environment .... ..... .... .. 84 Fuel consum ption, Fuel, Refuelling .. .... ..... .... ..... .... ..... .... .. 86 C atalytic converter, Exhaust gases .... .. 88 Brakes ... ..... .... ..... .... .... ..... .... ..... .... ..... .... .. 92 Wheels, Tyres ..... .... .... ..... .... ..... .... ..... .... .. 96 Roof racks, Carava n and trailer towing ... ..... .... 102 S elf-help .... .... ..... .... .... ..... .... ..... .... ..... .... 106 If y ou ha ve a problem .... .... ..... .... ..... .... 128 Maintenance, Inspection System .. ..... .... ..... .... ..... .... 130 Vehicle care .. ..... .... .... ..... .... ..... .... ..... .... 140 Technical Data .. .... .... ..... .... ..... .... ..... .... 144 Index . .... ..... .... ..... .... .... ..... .... ..... .... ..... .... 158

2

In Brief

In Brief

Key nu mbers, Code numbers Remove key number from keys. The key number is specified in the vehic le docum ents and in the C ar Pass 3. Alloy wheels 3: ma ke a note of the key identifier code. Elec tronic imm obiliser, infotainment sy stem 3: The code numb ers are specified in the Ca r Pass. Do not k eep the Car Pass in the vehic le. 6 Further information – p ages 28, 29, vehicle recomm issioning – page 139.

Picture no: 14088h.tif

To unlock the vehic le and open the doors: With key in lo ck turn key towards fro nt of vehicle or press button c on th e remote con trol 3, pull door handle and o pen door Rad io remote control 3 : Press button c once - only driver’ s d oor is unloc ked; press button c twice - all d oors are unlock ed. To unlock the doors from insid e: Pull up on lock button. 6 Door lock s – page 30, electronic immobilizer – p age 29, radio remote control 3 – page 31, central loc king sy stem 3 – p age 33, anti-theft locking system 3 – page 33.

In Brief

Pi cture no: 13471h.tif

Pict ure no: 13457h.tif

To unlock and o pen the luggage c ompartm ent: Turn the key anticloc kwise to horizo ntal position and back to the vertical position

Front seat adjustment: Pull h andle, slide seat, release handle, audibly engage seat in positio n

Alternatively press button c on the remote control 3 twice, press button and open tailgate

Nev er adjust the seat while driving. It could move in a n uncontrolled manner when the ha ndle is pulled.

6 Mechanical unlocking – page 30, radio remote control 3 – page 31, central lock ing sy stem 3 – page 33, tailgate – pag e 30.

6 Seat position – page 39, storage tray under seat 3 – page 46.

9 Warning Do not sit nearer than 10 inches (25 cm ) from the steering wheel, to p ermit safe airbag deploy ment.

3

Picture no: 13458h.tif

To adjust the front seat backrest: Turn the handwheel

Move seat bac krest to suit sea ting position. Do not lea n on seat back rest whilst adjusting it. 6 Sea t position – p age 39, folding the front passenger seat – page 42.

4

In Brief

Pi cture no: 13459h.tif

To adjust height 3 of front seat: Pull lever on side

Lift lever a nd relieve som e weight from seat to raise it or press down on seat with body weight to low er it. Never adjust the sea t while driving. It could move in an unc ontrolled m anner when the handle is pulled. 6 S eat position – pa ge 39.

9 Warning Do not sit nea rer than 10 inches (25 cm) from the steering wheel, to perm it safe airb ag deployment.

Pict ure no: 15137h.tif

To adjust the height of front seat head restraints: Tilt forward to unlock, ho ld firmly and adjust height, release 6 adjusting rear seat head restraints – pag e 40, head restraint position – page 39, head restraint removal – page 39.

Picture no: 12246h.tif

Adjusting interior mirror: Swivel mirror hou sing

S wivel lever on underside of m irror housing to reduce d azzle at night.

In Brief

Pi cture no: 12247h.tif

To adjust exterior mirrors: Manually - press edge of relevan t mirro r; Electrically 3 - using four-way switch in driver’s door Four-way switch 3: Mov e rocker switch to the left or right - the four-way switch adjusts the correspond ing mirror. The exterior m irrors can be retrac ted (e.g. when p arking in tight sp aces) through slig ht pressure on the mirror housing. Reposition the m irrors before starting off. 6 Further inform ation – page 65.

Pict ure no: 13461h.tif

Fitting seat belt: Draw seat belt smooth ly from inertia reel, guide over sho ulder and engage in buckle The belt must not b e twisted at any p oint. The lap b elt must lie snugly a gainst the body. The back rest m ust not be tilted back too far (recommended tilting angle approx. 25 °). To relea se belt, press red button on belt buckle. 6 Seat belts – pages 50, 52, airbag systems 3 – pag e 56, seat position – page 39.

Picture no: 15678t.tif

Disengaging steerin g colu mn lock: To release th e lock, move the steering wheel slightly and turn the key to position 1 Positions: 0 = Ignition off 1 = S teering released , ignition off 2 = Ignition on, S ta rting – page 15, electronic immobiliser – page 29. Remove key and lock steering wheel – pag e 16.

5

6

In Brief

In Brief 1

Page Door window defroster v ents ..... .... .. 73

2

Side air v ents .... ..... .... ..... .... .... ..... .... .. 73

3 4

.... .... .... ..... .... ..... .... ..... .... .... ..... .... ... Pa ge 21

Ashtray 3 ... ..... .... ..... .... .... ..... .... ..... .. 49 or storage compartment

Front pa ssenger airbag 3 . .... ..... .... ..57

22

Cigarette lighter 3 .... .... .... ..... .... ..... .. 49

Heating and ventila tion system, air conditioning sy stem 3 .... ..... .... .. 72

23

Infotainment sy stem 3 .... ..... .... ..... .. 26 or storage compartment

5

Centre air v ents ..... .... ..... .... .... ..... .... .. 73

24

Glov e com partment with cov er 3 . 47

6

Haza rd warning lights... .... .... ..... .... .. 11

7

Display for time, date, outside tem peratures, infotainment sy stem 3 . .... .... ..... .... ..24

8

Turn signal, headlight flash, dipped beam, main beam ... ..... 10, 11

9

Horn . .... .... ..... .... ..... .... ..... .... .... ..... .... ..11

10 Instruments... .... ..... .... ..... .... .... ..... .... .. 18 11 Wind screen wiper, windscreen washer system, rea r window washer system 3 ... .... .. 12 12 Fog lights 3 .. .... ..... .... ..... .... .... ..... .... .. 67 13 Light switch .. .... ..... .... ..... .... .... ..... 10, 66 14 Fog tail light . .... ..... .... ..... .... .... ..... .... ..67 15 Headlight range adjustment 3.. .... .. 67 16 Bonnet release lever . ..... .... .... ..... .... .. 37 17 Ignition switch with steering column lock (hid den) .. 5 18 Accelerator pedal . .... ..... .... .... ..... .... ..82 19 Brake pedal . .... ..... .... ..... .... .... ..... .... ..92 20 Clutch pedal .... ..... .... ..... .... .... ..... .... .. 83

77

8

In Brief

Control indicato rs

S EPS

A

Engine oil l ev el 3: see p ages 18, 132. Electronic power steer ing 3: see p age 18. Engine electronics, immob ilizer, fault see p ages 19, 29, 90.

Z

Exhaust em issi on: see p ages 19, 89.

O

Turn sig na l light s: see p age 19.

C

Main beam : see p ages 10, 19, 66.

u

Anti- lock b rake system 3: see page 94.

R

Brak e system: see pages 20, 136.

p

Alt ernat or: see page 20.

Lighting Li ght switc h, st alk positions: see page 66,

7 8

Li ghts off,

9

Dipped b eam , ma in beam,

Pa rking lights,

I

Engine oil pressur e: see page 21.

0

Courtesy li ght: see page 68.

Y

Fuel lev el : see pages 21, 23, 87.

>

Fog lights 3: see page 67.

v

Airb ag systems 3 , belt tensioners: see pages 51, 60.

r

Fog tail l ight: see page 67.

C

Main beam : see pages 10, 19, 66.

O

Tur n sig nal lig hts: see page 19.

?

Hea dlight range adj ust ment 3: see page 67.

¨

Hazard w arning lig hts: see page 11.

In Brief Climate control

x

Air distri bution: see p age 75,

K J V

Windscreen wipers

Air flow: see p age 75.

to foot well, to wind screen, front door wind ow s and foot well, to wind screen and front door windows,

M

to head area ab ov e adjustable air vents,

L

to head area ab ov e adjustable air vents and to foot well.

Ü

Hea ted rear wind ow: see p age 74.

4

Air recircula tion system: see p age 74.

5

Outside air intak e: see p age 74.

n

Air condit ioning system 3 : see p age 78.

St alk p osi tions: see page 12,

§ $ % &

Miscellaneous

e

Central l ocking system with rem ote control 3 loc king – see pag e 33.

c

Central l ocking system with rem ote control 3 unlocking – see page 33.

m

Central l ocking sw itch 3 : see page 34.

j

Horn, see page 11.

O ff, Timed interval w ipe, Sl ow , Fast

Date, time, inform ation display, infotainment system Tripl e i nfor mation d isplay 3: see page 24,

Ö

O n button for date and time

;

Setting buttons for date and time

9

10

Light 7 = 8 = 9 =

In Brief

Pi cture no: 13462h.tif

switch: Off Parking lights Dipped beam or main beam

Pull 0

=

Courtesy lig ht

Press >

=

Fog lights 3

Press r

=

Fog tail light

6Further information – page 66, head lig ht warning device – page 15, head lig ht ra nge adjustment 3 – pa ge 67, day tim e running lights 3 – pa ge 66.

Pict ure no: 14052h.tif

Main and dipped beam switch: Main beam = Push stalk forward Dipped beam = Pull stalk toward steering wh eel The blue control indicator C is illuminated when main b eam is on.

Picture no: 14053h.tif

Headlight flash: Pull stalk towards steerin g wheel

In Brief

Pi cture no: 14054h.tif

Operating turn signal lights: Lever in rest position Righ t turn = Upwards Left turn = Downwards When the steering wheel is turned back, the lev er automatically returns to its original position. This will not hap pen when making a m inor steering manoeuvre such as changing lane. When lane chang ing, move lev er to resista nce point. When released , the lever will spring back.

Picture no: 11130H.t if

Hazard warning lights: On = Press ¨ Off = Press ¨ again

When the button is pressed, its control indica tor flashes in time with the haza rd warning lig hts.

Picture no: 15140h.tif

Horn operation: Press j

6 Airb ag systems 3 – page 56.

11

12

In Brief

Pi cture no: 14055h.tif

Pict ure no: 14056h.tif

Windscreen wipers: Move stalk up § = Off $ = Timed interval wipe

Operating windscreen washer system: Pull stalk towards steering wheel

% = & =

6 Further information – page 137.

Slow Fast

The wipers w ill swipe for a few strok es.

Picture no: 14057h.tif

To operate rear windo w wiper and washer systems: Wiper on = Push stalk forward Wiper off = Pull stalk towards steering wheel Washer = Push stalk forward an d hold 6 Further inform ation – page 137.

In Brief

Picture n o: 11461H.tif

To clear misted o r icy windows: Turn the rotary switc hes fo r temperature and qu antity of air clockwise, set air distribution to V To switch on the air conditionin g 3, pu ll temperature switch n O pen side air vents as necessary and direct them tow ards the door windows. 6 Climate control – page 72, air conditioning sy stem 3 – page 78.

Picture no: 11125H.t if

Heated rear window: On = Pull fan switch Ü Off = Press fan switc h Ü Switch off as soon as rear vision is clear. 6 Further information – page 74.

13

14

In Brief Before starting off, check: z Tyre pressure and condition - see pages 98, 152. z Engine oil level a nd fluid levels in engine compartment – see pages 131 to 137. z All windows, mirrors, exterior lig hting and number plates are free from dirt, snow and ice a nd operational. z Do not place any objec ts in front of the rear window, on the instrument panel or in the area in which the a irba gs inflate.

Pi cture no: 15141h.tif

Pict ure no: 16178h.tif

Manual transmission

Exhaust gases are poisonous

Enga ging reverse gear on vehicles with release ring on gear lev er: with vehicle stationary, 3 seconds after depressing the clutch pedal lift ring, mov e gear lev er to the left a nd engage gear.

Exhaust gases contain carbon monoxide, whic h is extrem ely poisonous b ut is od ourless and colourless.

Enga ging reverse gea r on v ehicles without release ring on gear lev er: with vehicle stationary, 3 seconds after depressing the clutch ped al move gear lev er to the right and engage gear.

Also avoid driving with the lugga ge compartment op en. O therwise exhaust fumes could penetrate the vehicle interior.

If the gear does not engag e, set the lever in neutral, release the clutch pedal and depress again; then repeat gear selection.

Therefore nev er inhale exhaust gases, and never run the engine in an enc losed space.

z Seats, seat belts and mirrors are correctly a djusted . z Check brakes.

In Brief

15

Warning buzzers When the vehicle is parked and the driv er’s door is opened the warning buzzer w ill sound if: z the ignition key is in the ignition switch 3 z parking lights or dipped beam on 3.

Picture no: 15582a.tif

To start the engine: Depress clutch and brake pedals, do not ac celerate, petrol engin e: key to 3; release key once en gine is running Before restarting or sw itching off the engine, turn key back to 0. To switch on the ignition, only turn the k ey to 2. 6 Electronic im mobilizer – p age 29, further inform ation – page 106.

Pict ure no: 13463h.tif

Releasing the h and brake: Raise lever slightly, Press unlock button, Lower lever fully And now "Have a good journey!" Driv e ca refully , econom ic ally and w ith the environment in mind. While driving, d o not do anything that could distra ct you.

16

In Brief When parking: z Always ap ply hand brak e firmly . O n slop es apply the hand brake as firmly as possible. z Enga ge first gear or reverse. z C losing windows and sun roof 3 . z Turn steering wheel until lock is felt to eng age (anti-theft protection). z Engine cooling fan may run on after the eng ine has been switc hed off.

Pi cture no: 15143h.tif

Parking the vehicle: Apply handbrake firmly, engine o ff, remove key, lock steering wheel, lock vehicle

To lock, turn the key in the lock toward the rea r of the vehicle or press button e on the rem ote control. To activate the anti-theft locking system 3, turn the k ey tow ard the rea r of the vehicle twice or press button e on the remote control twice. 6 Further inform ation – pages 29, 82, radio remote control 3 – page 31, central lock ing sy stem 3 – page 33, vehic le decommissioning – page 139.

z Do not park vehicle on easily ignitable surfaces as the hot exhaust system temperatures could cause the surface to ignite.

Picture no: 15218H.Tif

Service work, Maintenance

We rec om mend that y ou entrust all work to y our Vauxhall Authorised Repairer, who can p rov id e y ou with reliable service and correc tly perform a ll work according to factory instructions. 6 If you have a p roblem– page 128, service interva l disp la y – page 130.

In Brief Genuine Vauxhall Parts and Accessories We recommend that you use " Genuine Vauxhall Parts a nd Accessories" and conversion parts released expressly for your vehicle ty pe. These parts have undergone special tests to establish their reliab ility , safety and specific suitability for Vauxhall vehicles. Despite continuous market monitoring, we cannot assess or guarantee these attributes for other products, ev en if they have been granted approva l by the relevant authorities or in som e other form.

"Genuine Vauxhall Parts and Accessories" and conversion parts approved by Vauxhall c an be ob tained from y our Vauxhall Authorised Repairer, w ho c an also provid e expert Va ux ha ll advice on permitted tec hnical c hanges and ensure correct installation.

9 Warning C arry out regularly the check s rec om mended in the indiv idual sections of this Owner’ s M anual. Ensure that your v ehicle is serv iced at the service intervals spec ified in the Serv ic e Booklet. We recommend that you entrust this work to your Vauxhall Authorised Repairer. Hav e faults remedied without d elay! C onsult a w orkshop. We recommend your Vauxhall Authorised R epairer. If necessary , interrupt your journey. 6 Maintenance – page 130.

17

That was a brief lo ok at the most important information for your first drive in your Agila.

The remain ing ch apters of the Owner’s Manual con tain impo rtant information on operatio n, safety and maintenanc e as well as a com plete index.

18

In struments

Instruments

Pict ure no: 15216h.tif

Control indicators .... ..... .... ..... .... .... ..... . Instrument display ... ..... .... ..... .... .... ..... . Information display 3 .. .... ..... .... .... ..... . Radio reception 3 .... ..... .... ..... .... .... ..... . Infotainm ent system 3 . .... ..... .... .... ..... . Mobile telephones a nd radio equipment 3. ..... .... ..... .... ..... .... .... ..... .

18 22 24 26 26 26

Control indic ators

The control indica tors described here are not p resent in all vehicles. The description applies to all instrum ent versions.

S

Engine oil l ev el 3 The engine oil lev el is check ed autom atic ally.

EPS 1)

Picture no:

Electric p ower steering 3 The control indicator illuminates for a few seconds when the ignition is switched on. Illumination while driving indicates a fault. Driving m ay be continued. M ore force is required for steering. Consult a workshop. We recommend your Vauxhall Authorised Repairer.

Illum inated: Engine oil lev el too low. Check oil level and top up as necessary. S ee page 132.

1)

EPS = E lectronic P o wer Steering.

Instruments

19

O Turn signal lights When the turn signal is activated, the corresponding control indica tor flashes. Rapid flash: A turn signal bulb is faulty. Bulb replacem ent – see page 122. Both control indic ators flash when the hazard warning lights are activated.

C

Ma in beam The control indicator is illum ina ted when ma in beam is on a nd during headlight flash – see page 10.

A

Pi cture no: 15217h.tif

Z

Picture no:

Eng ine electr oni cs, imm obilizer The c ontrol indicator illumina tes for a few seconds when the ignition is switched on.

Exhaust em ission Illum inates when the ignition is switched on. Goes off shortly after the engine sta rts.

Illuminates when the engine is running Fault in the engine electronics sy stem. The electronic s system sw itches to lim p-hom e mode. Fuel consumption may increase and the d riv eability of the vehicle m ay be impaired – see p age 90. C onsult a workshop. We recommend your Vauxhall Authorised Repairer.

Illum inates when the engine is running Fault in emission control system . The permitted em ission limits m ay b e exc eeded. Consult a workshop. We recommend your Vauxhall Authorised Repairer.

If it flashes when the ignition is on: Fault in the electronic immobilizer sy stem; the engine ca nnot be started – see page 29.

If it flashes when the engine is running: Fault that can lead to d estruction of the catalytic converter is indicated – see page 89. Consult a workshop im mediately. We rec om mend that you consult your Vauxhall Authorise Rep airer.

u Anti -lock b rake system (ABS ) 3 see page 94.

20

In struments p Alt erna tor Illuminates when the ignition is switched on. Goes off shortly after the engine starts. Illuminates when the eng ine is running S top the vehicle and switch off the engine. The battery is not being charged. Eng ine cooling may be interrupted. Contact a workshop. We recommend your Vauxhall Authorised Repa irer.

R

Pi cture no: 15216h.tif

Brak e system The c ontrol indicator illumina tes when the ignition is switched on if the hand brake is applied or if the brak e fluid level is too low. Further information – see pa ge 136.

9 Warning Illum inated when the hand brak e is not applied: Stop the vehicle; interrupt y our journey immediately . Consult a work shop. We recomm end your Vauxhall Authorised Repairer.

Picture no:

9 Warning Illuminated together with the control indicator for the Anti-lock Brake Sy stem u : The b ra king force on the rear wheels is not being regulated. The vehicle may swerve during braking. Consult a workshop . We recommend y our Va ux ha ll Authorised Repairer.

Instruments

21

9 Warnin g When the eng ine is off, considerably more force is needed to brake and steer. Do not remove key until v ehicle has com e to a standstill, otherw ise the steering colum n lock could engage unexpectedly . C ontact a workshop. We recommend that you consult your Vaux hall Authorised Repairer.

Y I

Pi cture no: 15217h.tif

Eng ine oi l pressure Illuminates when the ignition is switched on. Goes off shortly a fter the engine starts.

Picture no:

Illum inates when the engine is running Engine lub ric ation may be interrupted . This may result in dam age to the engine and/or lock ing of the drive wheels:

Fuel lev el 3 Illuminated : Low fuel level. Fuel gauge in reserve area. If it flashes: Fuel reserve used up, fill up imm ediately.

1. Move out of the flow of traffic as quickly as possible without imped ing other vehicles.

N ever let the tank run dry!

2. Depress clutch.

v

3. Put the transmission in neutral 4. Sw itch off ignition.

Erra tic fuel sup ply can c ause catalytic converter to overheat – see page 88. Airb ag system s 3 , belt tensioners see pages 51, 57.

22

In struments

Pi cture no: 12941h.tif

Instrum ent display Tachom eter 3 Indicates engine speed.

Warning zone: m aximum permissible engine sp eed ex ceeded ; danger to engine.

Speedometer1) Indicates the vehicle speed .

Picture no: 11141H.tif

Odom et er Switchable between overall odometer and two trip odometers A or B.

Trip odometer S witc hab le from overall odometer (O DO) to trip odometer A (TRI P A) or trip odometer B (TRI P B). Press the reset knob briefly to switch between the three options.

Overal l odometer With ignition on, display of total miles driven – "O DO" 1 ) app ears on the display .

Reset trip odometer A or B by p ressing and holding down the reset knob for app rox . 2 seconds. S ervice interval d isplay , see page 130.

1)

ODO = Od om eter.

Instruments

23

For physical reasons, the engine temperature gauge show s the coolant temperature only if the coolant level is adeq uate. During operation the system is pressurised. The temp erature ma y therefore rise briefly to ov er 100 °C.

Pi cture no: 13465h.tif

Coola nt temperat ure d isplay Pointer in low zone = Engine operating temperature not y et reached Pointer between the z ones Pointer in upper (warning ) zone

= Normal operating temperature

Picture no: 13466h.tif

Fuel gauge Pointer in red zone or Y illuminated Pointer in red warning zone or Y flashing

= Reserve area

= Fill up immediately – see pag e 87.

N ever let the tank run dry! = Temperature too high: Stop vehicle and switch off eng ine. Danger to engine, check coolant level immediately – see page 134.

Because of the fuel remaining in the tank, the amount of fuel required to fill the tank ma y be less than the spec ified tank cap acity.

24

In struments Setting d ate and t ime Date and tim e c an either b e set manually or corrected autom atically with an R DS tim e signal1) 3.

12:01 17,0 °C FM 3 90,6 MHz REG

AS

RDS

TP

Some RDS tra nsmitters do not send correct tim e signals. If the incorrect time is display ed often, deactivate autom atic tim e synchronisation 3 a nd set the tim e manually.

8:56 5 ,5°C 07.04.2004

The automatic setting is indicated by Ö in the display.

Pict ure no: 17913s.t if

Picture no: 17914s.tif

Manual setting Infotainment system off. Press Ö and ; nex t to the d isplay as follows:

Information display 3

Tripl e inform ation d isp lay Display of time, outside tempera ture and date/infotainm ent system if it is switched on.

Press Ö for a pprox. 2 seconds: Day flashes ; : S et day

When the ignition is off, the time, date and outside tem perature can be made to appear for approx. 15 seconds by briefly pressing one of the two buttons on the right-ha nd side of the display .

Ö : Month flashes ; : S et month Ö : Y ear flashes ; : S et year Ö : Hours fla sh ; : S et hours Ö : Minutes flash ; : S et minutes Ö : C lock is started.

1)

RDS = Rad io D ata S ys tem.

Instruments Dea ctivating and activ ating autom atic setting func tion 3 Infotainm ent system off. Press Ö and ; nex t to the display as follows: hold down Ö for approx. 2 sec., clock display is now in setting mode, Press Ö tw ic e (until year flashes). Press Ö a nd hold down for approx. 3 seconds until } flashes in d isplay and tex t "RDS TIME" appears (y ears flash during this time), Press ;; d isplay of: RDS TIME 0 = O ff. Press ;; d isplay of: RDS TIME 1 = O n Press Ö three times.

25

Fault d isplay An F in the display ind icates a fault. H ave the cause rem edied. We recomm end that y ou consult your Vaux hall Authorised Repairer.

8:56 -5 ,5° C 07.04.2004

:

Picture no: 17913s.tif

Outside temp era ture A fall in temp erature is indicated immed iately and a rise in temperature after a tim e delay. If outside temp erature d rops below 3 °C , the symbol : appears in the information display as a w arning for icy road conditions. When tem perature increases to at least 5 °C , the : symbol goes out.

9 Warning C aution: The road surface ma y already be icy even though the disp lay indicates a few degrees above 0 °C.

26

In struments

Radio reception

3 Ca r radio reception differs from domestic radio reception: As the vehicle a ntenna is rela tiv ely near the ground , the broa dcasting com panies cannot guarantee the same quality of reception as obtained w ith a domestic radio using an overhead antenna. z Changes in distance from the transmitter, z multi-pa th recep tion due to reflection and z shadowing may cause hissing, noise, d istortion or loss of reception altogether.

In fotain men t system 3 The infotainment sy stem is opera ted as described in the operating instructions supplied.

Mobile telephones and radio equ ipment 3 The Vauxhall installation instruc tions and the op erating guidelines prov ided by the telephone manufacturer m ust be observed when fitting and op erating a m obile telephone. Fa ilure to do so could inv alidate the vehicle’s operating permit (EU Directiv e 95/54/EG). Prerequisites for fault-free operation: z Professionally installed ex terior antenna to obtain the ma ximum range possible z Maximum tra nsmission power 10 Watt, z Installation of the telep hone in a suita ble spot (see inform ation on p age 61).

Instruments O btain advice on pred eterm ined installation locations for the ex ternal antenna and equipment holder and w ays of using devices with transmission power of more tha n 10 Watts. We recommend that you consult y our Vauxhall Authorised Repairer, who will ha ve brackets and various installation kits available as accessories and w ill install them in accordance with reg ulations.

For rea sons of safety , we recomm end that you do not use the p hone while driving. Even use of a hands-free set can be a distraction while driving. Be sure to observe any country -specific reg ulations.

9 Warning When used in the vehicle interior, mobile telephones and radio equipment (C B) with integrated antenna m ay ca use malfunctions in the vehicle electronics. Mobile telephones and radio equip ment (CB) should only be used with an antenna fitted on the vehicle exterior.

27

28

Keys, Doors, Bonnet

Keys, Doors, Bonnet

Replacement keys

Car Pass

The key is a c onstituent of the electronic immobiliser. Ordering keys from a Vauxhall Authorised Repairer g uarantees problem free op eration of the electronic immobiliser.

The Car Pass contains all of the vehicle’s data and should therefore not be kept in the vehicle.

Keep the sp are k ey in a safe spot. Locks – see page 143.

Loc k cylinders Designed to free-wheel if they are forcefully rotated without the correct k ey or if the correct key is not fully inserted. Electronic immobilizer .. .... ..... .... .... ..... . Mechanica l unlocking or lock ing of ind iv idual doors. .... ..... .... ..... .... .... ..... . Radio remote control 3 .... ..... .... .... ..... . Central locking with vehic le key 3, central locking with remote control 3 ... .... ..... .... ..... .... ..... .... .... ..... . Child safety locks . .... ..... .... ..... .... .... ..... . Bonnet ..... .... .... ..... .... ..... .... ..... .... .... ..... .

29 30 31

33 37 37

To reset, turn cy linder with the c orrect key until its slot is vertica l, remove key and then re-insert it. If the cylinder still free-wheels, turn the key through 180° and rep eat op eration.

Hav e y our Car Pass on hand when consulting a Vauxhall Authorised Repa irer.

Keys, Doors, Bonnet

29

If the control indic ator A illum ina tes after the engine has been started, there is a fa ult in the engine electronics – see pag e 90. Not e The immobilizer does not lock the doors. After leaving the vehicle, therefore, always lock it – see page 33.

Pi cture no: 15761t.tif

Electronic immo bilizer

The sy stem checks whether the vehicle m ay be sta rted using the key that has been inserted. If the k ey is " authorised" , the vehic le can b e started. This check is ca rried out via a transponder housed in the key. The electronic immobiliser is automatically activated when the key is removed from the ig nition switch.

Pict ure no: 12943h.tif

Control i nd icator A for im mobil izer Control indica tor A illuminates briefly when the ig nition is sw itched on. If the control indicator flashes w hen the ignition is on, there is a fault in the sy stem; the engine cannot be started. S witc h off the ignition and then rep eat the start attempt. If control indicator A continues to flash, try to start the eng ine using the spare k ey and consult a work shop. We recomm end your Vaux hall Authorised Repairer.

30

Keys, Doors, Bonnet

Pi cture no: 18155h.tif

Mechanical unlocking or lo cking of individual doors (versions without radio remote c ontrol 3 and central locking system 3) Front doors To unlock : Turn k ey in lock towards front of vehicle as far as it will go. Return key to the vertical position and remove. Pull door handle. To lock: With door closed, turn key towards rea r of vehic le as fa r a s it will go. Turn k ey ba ck to vertic al position and remove. O perating from the inside Pull or press the interior lock b utton.

Pict ure no: 13506h.tif

Ta ilgat e To unlock: Turn the key to the left as far as the stop, turn bac k to the vertical p osition and withdra w. The lock is released b y pressing the button. To lock : Turn the key to the right as fa r a s the stop, turn bac k to the vertical p osition and withdra w.

Picture no: 13746h.tif

O pen luggag e c om part ment There are two handles on the inside of the tailgate to aid in c losing.

Keys, Doors, Bonnet Note z Fitting of accessories on the tailgate will increase its weig ht. If it becomes too heavy, it will then not stay open. z The number plate ca n only be clearly seen if the tailgate is closed. It is therefore not perm itted to drive with the ta ilg ate open.

9 Warning

Do not d riv e with the luggage com partment open, e.g. when transporting bulky objects, since toxic exhaust gas c ould penetrate the interior.

Pict ure no: 13468h.tif

Radio remote c ontrol 3

The radio remote control is integrated in the key. Used to operate: z central lock ing sy stem, z mechanical anti-theft locking system 3. The radio remote control has a range of approx. 3 m etres. This range can be affected by outside influences. Aim the remote control at the vehicle to operate.

Picture no: 13469h.tif

Handle radio remote c ontrol with care, protec t from moisture and high temperatures a nd avoid unnecessary operation. The ha zard warning lights come on to indicate that the remote c ontrol is operational. C entra l lock ing w ith radi o rem ote control 3 , see page 33. Mechanic al anti -theft locki ng system w ith radi o rem ote control 3 see page 33.

31

32

Keys, Doors, Bonnet

Fault If the central locking system cannot be opera ted with the radio rem ote control, it may be due to the follow ing: z The range of the radio remote control has been exceed ed. z The ignition k ey is in the ignition lock . z The doors are not closed prop erly. z Remote control b attery v olta ge is too low. Battery replac ement - see next column. z Interference from higher-power radio waves from other sources. To eliminate the cause of the fault, contact your Vauxhall Authorised R epairer. Manual unlocking and locking w ith the vehic le key - see page 30.

Pict ure no: 13470h.tif

Picture no:

Rem ote control b attery rep lacement Replace the battery as soon as the range of the radio remote control begins to shrink.

O pen up remote control. Replace battery (battery type - see pag e 154). Note insta lla tion position of b attery (positive term ina l points down).

Remove screw on the underside of the remote control k ey with a screwdriver and remove cover.

C lose remote control and engage audibly. Insert remote c ontrol unit in key section. C lose the cover and screw in place.

The transponder for the imm ob iliser is loca ted in the key. Ensure that it is not damaged or released.

Mak e sure that you dispose of old batteries in accordance with env ironmental protec tion regulations.

Detach the remote control unit from the key section by pressing in the buttons. Ap ply screwdriver and open rem ote control on b oth sides b y ma king a slight turning movem ent. S ee figure abov e.

Keys, Doors, Bonnet

Pi cture no: 15144h.tif

Cen tral locking with vehicle key 3, central locking with remote con trol 3

For doors and lugga ge c om partment. To lock : Turn key in front d oor lock toward rea r of vehic le, turn key b ack to vertical position and remove. – or – Press button e on radio rem ote control 3 – or from the inside – With doors closed, press button m on driver’s door arm rest/pull. See next pag e, figure 12273 H.

Pict ure no: 15146h.tif

Lock ing w ith mechanic al anti-theft loc king syst em 3 All doors must be closed. After lock ing, turn the key in one of the front door lock s tow ards the rear of the vehicle again, turn it back to the horiz ontal p osition and remove. – or – no more than 2 seconds after locking, press button e on the rem ote control 3 ag ain. Interior lock buttons on all doors are blocked from opening.

9 Warning Do not use the system if there are people in the vehicle! The d oors can only b e unloc ked from the insid e if the ignition is on.

33

Picture no: 15145h.tif

To unlock : To unlock only the driver’ s d oor: Turn k ey in driver’s door lock towards front of vehicle onc e, then move back to vertical position a nd remove. – or – Press button c on radio rem ote control 3 once. – or – Press button m on driver’ s door arm rest/ pull. S ee nex t page, figure 12273 H.

34

Keys, Doors, Bonnet

To unlock entire vehicle: Turn key in front d oor lock toward front of vehic le twice, turn key bac k to vertical position and remove.

Not e z To prevent the driv er from being ina dvertently locked out, the b utton on the driver’s door cannot be depressed when the door is open.

– or –

z The lock b utton will not spring up if the door ha nd le is raised w hen the door is being c losed .

Press button c on radio rem ote control 3 again within 5 seconds – or –

z 30 seconds after unlocking using the radio rem ote control 3, the doors lock again automatically if no d oor is opened .

Press button m on driver’ s d oor a rm rest/ pull. S ee figure 12273 H. If the mec hanical anti-theft lock ing system 3 is engaged, the doors cannot be unlock ed using button m on the driver’s door arm rest/pull.

Pict ure no: 12250h.tif

Central l oc king sw itch for locking and unlock ing the doors from insi de the vehicle Press button m on d riv er’s door ha ndle: all doors are locked or unlock ed. If the m echanical anti-theft locking sy stem 3 is eng aged, the doors cannot b e unlocked with this button.

Keys, Doors, Bonnet z If the driver’s door is open or the ignition is on, unlocking and lock ing with the ra dio remote control 3 is not possible. z Unlocking is only possib le with the k ey if the anti-theft locking system is switched on, so k eep the spare key av ailable in a safe place!

Central l oc king 3 the luggag e compa rtment The luggage compartment is loc ked and unlocked via the central loc king sy stem. The central lock ing sy stem and a nti-theft lock ing sy stem 3 for the doors cannot b e op erated via the tailgate lock.

35

36

Keys, Doors, Bonnet

Pi cture no: 13471h.tif

Unlock ing the tai lgate w hen the doors are lock ed wit h cent ral lock ing system Turn the key anti-clockwise from the vertic al position as far as it w ill go. The key springs ba ck to the centre position. The tailgate is then unlock ed a nd can be opened by pressing the button.

Pict ure no: 13472h.tif

After closing the tailgate, turn the key cloc kwise as far as it will go. The k ey springs back to the centre position and the tailg ate is locked. Remove the key . The key ca n only be removed when in the vertical p osition.

Picture no: 13746h.tif

O pen the luggage com part ment There are two handles on the inside of the tailgate to aid in c losing.

Keys, Doors, Bonnet

37

Note z Fitting of accessories on the tailgate will increase its weig ht. If it becomes too heavy, it will then not stay open. z The number plate ca n only be clearly seen if the tailgate is closed. It is therefore not perm itted to drive with the ta ilg ate open.

9 Warning

Do not d riv e with the luggage com partment open, e.g. when transporting bulky objects, since toxic exhaust gas c ould penetrate the interior.

Picture no: 11155H.t if

Child safety locks

9 Warning Use the child safety loc k whenever children a re occupying the rea r seats. Disregard may lead to injuries or end ang er life. Vehicle p assengers should be inform ed a ccord ingly . Push the latch on rear door locks down: door cannot b e opened from the inside.

Bon net

Picture no: 11165H.tif

To open the bonnet, pull the release lever, located on the driv er’s side b elow the instrument panel. The bonnet will then be unlocked and will partially open. R eturn release lever to its original position.

38

Keys, Doors, Bonnet

Pi cture no: 16179h.tif

Picture no: 11167H.t if

The safety catch is located above the radiator grille at the c entre of the bonnet. O pen the bonnet by moving the catch to the left and lifting the bonnet.

To hold the bonnet open, insert the support rod located on the right-hand side of the vehicle (as viewed in the direction of travel) in the slot on the und erside of b onnet.

Any dirt or snow on the b onnet can slide down towards the wind screen when the bonnet is opened a nd block the air intak e – see page 80.

Before c losing bonnet, press support rod firmly into its retainer. Lower the bonnet gradually and then allow it to fall into the lock under its own weight. Check tha t the bonnet is lock ed in position by pulling at its front edge. I f it is not engaged, repea t the procedure.

Seats, Interior

39

Seats, Interior

Lug gage compartment enlargem ent Lashing eyes 3 .... .... ..... .... ..... .... .... ..... . Notes on loading . .... ..... .... ..... .... .... ..... . Lug gage compartment cover 3... ..... . Safety net 3 .... ..... .... ..... .... ..... .... .... ..... . Storage options in the v ehicle interior Notes on loading the vehic le .... .... ..... . Sun visors. .... .... ..... .... ..... .... ..... .... .... ..... . Ciga rette lig hter 3 ... ..... .... ..... .... .... ..... . Accessory socket . .... ..... .... ..... .... .... ..... . Ashtray 3 .... .... ..... .... ..... .... ..... .... .... ..... .

41 42 42 43 43 45 48 48 49 49 49

Pict ure no: 13473h.tif

Picture no: 13474h.tif

Seat position

Head restraints

Ad just driver’s seat such that with the driver sitting upright the steering wheel is held in the area of its upper spokes with the driver’s arm s slightly bent.

The centre of the head restraint should be at eye level. If this is not p ossible, a djust to highest position for ex tremely ta ll peop le or to lowest p osition for extremely short people.

Push passenger sea t as far back as possible. The seat b ackrests must not be tilted too fa r back (recommend ed tilting angle approx. 25 °).

9 Warning Do not sit nearer than 10 inches (25 cm ) from the steering wheel, to p ermit safe airbag deploy ment. Failure to observe the descriptions could lead to injuries whic h could be fata l. Vehicle passeng ers must be informed accordingly before starting-off.

9 Warnin g Failure to observe the descriptions could lead to injuries which could be fatal. Vehic le pa ssengers should be informed accordingly before starting off.

40

Seats, Interior

Pi cture no: 15137h.tif

Front hea d restraint a djustment Adjust the head restraints b y tipping them forward, holding and a djusting the height.

Pict ure no: 13741h.tif

To improve visibility when the front passenger seat is unoccupied or to fold down the front passenger seat, push the head restra int all the way down or remove.

Rea r hea d restraint a djustment To improve visibility when the rear sea ts are unoccupied or to fold down the rear seat backrests, press the detent springs on the guide sleev es to release the head restra ints and push them all the way down or remove them . See next column.

If the front passenger seat is occupied, adjust the hea d restraint to the appropriate lev el for the occ upa nt’ s b od y.

If the rear seats are occupied, adjust the rear head restraints to the occupants’ body size.

Picture no: 15148h.tif

Head restra int remova l Press the two d etent springs on the guide sleeves to release, remov e head restraint.

Seats, Interior

41

Luggage compartment enlargement Remove the luggage compa rtm ent cover 3. See pag e 43. Remove the p ush-in sleev es 3 for mounting the IS OFIX child restraint system 3; see the separate instructions for the ISO FIX child restraint sy stem. Remove the safety net 3 from the rec ess under the rear seat cushions as necessary.

Picture no: 13742H.t if

Fold ing rear seat ba ckrests Press the detent springs on the g uide sleeves to release the rear hea d restraints and push them a ll the way down or remove them (see prev ious pag e). Disenga ge the centre three-point seat belt from both buckles. The belt will retract fully – see page 55. Disenga ge one or both rear seat bac krests with the pushbutton and fold down onto the seat c ushion.

Picture no: 13743H.tif

Repositioni ng rear sea t bac krests Pull the outer seat belt forwa rd so it is not dam aged when the backrest is returned to an upright position. Eng age rear seat backrest audibly in position. Eng age the tongue of the centre threepoint seat b elt in the two buckles of the centre rea r seat. Install the lugg age comp artment cover 3 see page 43. Install the push-in sleeves 3 for mounting the ISO FIX child restraint system 3.

42

Seats, Interior Notes on lo ading see page 48.

Pi cture no: 16180h.tif

Folding d own the front pa ssenger seat 3 Push front passenger sea t head restraint all the way down or remove (see page 40). Slide front passenger seat back. Tilt passenger seat backrest forward by lifting the release lever. Repositioning the front passeng er seat bac krest 3 Press the release lev er forward, restore the front passeng er seat back rest to an upright position and aud ibly eng age.

Pict ure no: 13750h.tif

Lash ing eyes

3 Lashing eyes in the lugg age c om partment are for securing transp orted item s with lashing straps 3 or a luggag e net 3 to prevent them from slipping around. There a re a total of six lashing eyes in the lugg age compartment.

Seats, Interior

Pi cture no: 13744h.tif

Luggage compartment cover

3 To rem ov e, unhook the retaining strap s from the ta ilg ate. Remove the cover from the side guides and place it behind the seat backrests. Fit in reverse order. Do not place any heavy or sharp-edged objects on the cover.

Pict ure no: 11453h.tif

Safety net 3

When the rea r seat back rests a re folded down, the safety net is mounted behind the front seats. Pa ssengers must not be c arried behind the safety net.

43

Picture no: 11454h.tif

Fitti ng Folding rear seat backrests - see luggage compa rtm ent enlargement on page 41. There are two installation apertures in the roof frame above the front seats: Use the ignition key to unclip the cov er. Engage one side of the upper net rod in one side and then engage in the other side. C lose the cover. 6

44

Seats, Interior Rem oving Swivel tensioning strap leng th adjusters up ward and unhook straps from the eyes in the floor. O pen the cover of the installation apertures 3 in the roof fra me. Unhook up per net rod and close c ov er.

Pi cture no: 13748h.tif

Hook the safety net tensioning straps in the lashing eyes in the floor behind the front seat a nd tension.

Picture no: 13505h.tif

St owage of safety net Roll up the removed safety net and secure it with Velcro strip. Guide the safety net into the recess und er the rear sea ts.

Seats, Interior

Pi cture no: 13749h.tif

Storage o ptions in th e vehicle interior Stor age net s 3 on both sides of lugga ge com partm ent O n some versions, there are storage nets on the right and left walls of the luggag e compartment. Do not stow a ny heavy objects in the nets.

Pict ure no: 13751h.tif

45

Picture no: 13752h.tif

Storag e b ox in lug gage com partm ent 3 The storag e box is loc ated b ehind the left rear seat backrest in the luggage compartment.

S ecure the storage box at the back w ith knurled screws.

Fitting Folding down rear seat b ackrests – see page 41.

Removing To remove, rev erse sequence of operations.

With the tailgate open, tip the storage box forward and enga ge the recesses on the storage box on the locating pins.

Eng age the rea r seat back rests in sea ting position.

46

Seats, Interior

Pi cture no: 13480h.tif

Stor age tray 3 under front p assenger sea t Lift tray by grasping recessed edg e and pull forwards. Max im um load: 1 k g. To close the tray push it in and lock it in place.

Pict ure no: 15149h.tif

Rucksack 3 on the ba ck of a front sea t back rest Fasten securing belt for rucksack onto front seat back rest: feed both belt strap s between sea t and back rest. Feed belt straps through la shing eyes and tighten.

Picture no: 11473h.tif

Attach rucksack to b oth clips at top and secure to snap fastener at b ottom.

Seats, Interior Glov e com part ment Pull the handle to open.

47

Addit ion st orage options are found

z in the luggage net 3 on the ba ck of the rear ba ckrest,

z in the pockets 3 on the back of the front seat b ackrests,

z in the stow age compartment 3 in the centre console in front of the g ear lever.

z in the compartments 3 a t the side of the front seats,

Drink holder 3 There are two drink holders located in the centre console in front of the gea r lever.

z in the comp artments 3 in the door inner panelling, z in the stow age comp artment 3 b eneath the glov e c om partment,

48

Seats, Interior z The load must not obstruct the operation of the hand brak e and the gears or restric t the driver’s freed om of movement.

Notes on loading the vehicle z Heav y objec ts in the lug gage com partment should be placed as far forward as possible aga inst the engag ed rear seat backrests or, if the rear seat backrests are folded down, against the front seat b ackrests. If objects a re to be stacked, the heav ier objects should be placed at the b ottom. Unsecured objec ts in the luggage compartment would be thrown forward with great force in the event of heavy braking, for exam ple. z Secure heav y objec ts with lashing straps 3 a ttac hed to lashing ey es 3 – see page 42. If heavy loads slip when the vehicle is braked heavily or driven around a bend, the handling of the vehicle may chang e. z Loose objects in the luggage com partment should be secured ag ainst slipping using a luggage net 3 – see page 42. z Fit the safety net when transp orting ob jects in the luggage compa rtm ent with the rear seat back rests fold ed down – see page 43. z If the bac krests are not folded down when transporting objects in the lugga ge c om partment, they m ust be engaged in the upright position. See page 41.

z Do not drive with the luggage compartment op en, e.g. when tra nsporting bulky ob jects, since toxic ex haust g as could p enetrate the interior. z Weights, payload and roof loa d – see page 150.

Pict ure no: 13753h.tif

z Do not a llow the load to protrude ab ov e the upp er edge of the rear seat back rests, or above the upper ed ge of the front seat b ackrests if the rear seat back rests a re folded down. z The warning triangle 3 and first-aid kit (cushion) 3 m ust alway s be freely accessible. z Do not place any objects in front of the rea r window or on the instrument pa nel. They are reflected in the glass, obstruct the driver’s view and will be thrown through the vehicle, for insta nce in the event of heavy b ra king. z O bjects must not be stored in the airbag inflation area, beca use they could cause injury if the a irba g infla tes.

z Roof load s increase the vehicle’s sensitivity to crosswinds and has a negative affect on drivea bility due to an raised centre of gravity .

9 Warnin g Disregard of these notes c an lead to injuries which ma y be fatal. Vehicle passeng ers should be inform ed accordingly.

Su n visors Use the sun v isor to protect from glare by pulling it down and swiv elling it to the side 3.

Seats, Interior

Pi cture no: 16181h.tif

Cigarette lighter 3 In front centre console:

Press cigarette lighter with ignition switched on. S witches off autom atically when elem ent is glowing. Withdraw cigarette lighter.

Accessory socket The cigarette lighter socket ca n be used to connect electrical a ccessories.

Pict ure no: 16182h.tif

The socket is opera tional when the ignition is switched on. Use of the socket discha rg es the battery if the engine is not running. Do not d amage the sockets b y using unsuita ble plugs. The max imum power consumption of electrica l accessories must not exceed 120 watts. Do not c onnect any current-delivering accessories, e. g. electrical charging devic es or batteries. Elec trica l accessories connected to the socket must comply with the electrom agnetic comp atibility requirements la id down in DIN standard VDE 40 839. otherwise v ehicle malfunc tions may occ ur.

49

Picture no: 16183h.tif

Ashtray 3

To be used only for ash and not for comb ustible rubb ish.

9 Warnin g Disregard of these notes c an lead to injuries which ma y be fatal. Vehicle passeng ers should be inform ed accordingly. To open: Withdraw ashtra y. To empt y: Press ashtray cover down and withdraw ashtray.

50

Safety systems

Safety systems

Three-stage restraint system Comprising: z three-point seat belts z belt tensioners a t the front seats z airbag sy stems for driver a nd front passenger seats 3. The three stag es are a ctivated in sequence depending on the seriousness of the accident: z The automa tic seat belt locking devices prevent the belt strap from being pulled out and thus ensure that the v ehicle occupants are retained in their seats.

Seat belts. .... .... ..... .... ..... .... ..... .... .... ..... . Three-point seat belts .. .... ..... .... .... ..... . Belt tensioners. ..... .... ..... .... ..... .... .... ..... . Using the belts ..... .... ..... .... ..... .... .... ..... . Vauxhall Full S ize a irb ag system . ..... . Use of child restraint systems 3 ... ..... . Mounting brackets 3 for ISO FIX child restra int system s ... ..... .... ..... .... .... ..... . Ex terior mirrors..... .... ..... .... ..... .... .... ..... . Head restraints .... .... ..... .... ..... .... .... ..... . Sun visors, glove compartment .... ..... . Safety acc essories 3 .... .... ..... .... .... ..... .

51 51 52 54 56 62 62 65 65 65 65

z The seat belts on the front seats are tensioned on the autom atic retractors. As a result, the seat belts a re instantaneously tightened and the occupants are made aware of the deceleration of the vehicle at a v ery ea rly stage. This reduces the stress placed on the body. z The airbag sy stems a re also triggered in the ev ent of serious accidents and form a safety cushion for the occupants.

9 Warnin g The airbag sy stems 3 serve to supplement the three-p oint sea t belts and belt tensioners. The seat b elts must therefore always be worn. Disregard of these instructions may lead to injuries or endanger life. Vehicle passengers should be informed accordingly. Read the instructions sup plied w ith the child restraint system!

Safety systems

51

Testing the belts Plea se check all parts of the b elt system occasionally for dama ge a nd correct operation. H ave da maged parts replaced . In ca se of an accident, please replace overstretc hed belts and triggered belt tensioners. We recom mend consulting y our Vauxhall Authorised Repairer.

Seat belts

9 Warning Alwa ys wea r your seat belt, and that means a lso in urban traffic a nd when you are a rear sea t passeng er. I t can save your life! Pregnant women m ust alwa ys wear a seat belt – see page 54.

Do not mak e a ny alterations to the belts, their anchorages, the automatic retrac tors or the belt b uck les.

In the event of an accident, persons not wearing seat belts endanger their fellow occupants and themselv es.

Mak e sure that b elts are not da maged or trapped by sharp-edged objec ts.

Seat belts are designed to be used by only one person at a time. They are not suitable for children under 12 years of age or 150 cm unless an a ppropria te child restraint sy stem is used. For children up to 12 yea rs of ag e we recom mend the Vaux hall child restraint system – see page 63.

Pict ure no: 13461h.tif

Three-point seat belts

The vehic le is equip ped with three-point seat belts with automatic retractors and lock ing dev ices, allowing freedom of b od y movem ent although the spring tensioned belts alway s ensure a snug fit. For inform ation on p roper seat position, see p age 39. The belt has a "vehicle sensitive retractor" whic h is d esigned to lock during heavy acceleration or deceleration in any direction.

52

Safety systems

Belt tension ers

9 Warnin g

The front sea t belt systems incorporate belt tensioners. In the event of a head -on collision and d epending on the severity of the a ccident, the seat b elts are instantaneously tightened by the automatic retra ctors.

Have the cause of the fault remedied. We recommend that you consult your Vauxhall Authorised Repairer. The sy stem’s integrated self-diagnostics allows faults to be quickly remedied. Have y our C ar Pass on hand when consulting a Vauxhall Authorised Repairer.

Actua tion of belt t ensioners is indicated by illumination of control indicator v. The belt tensioners m ust be replaced after activation. We recomm end that y ou consult your Vauxhall Authorised Repairer. If the seat belts a re undamag ed the opera tion thereof is unaffected, even if the belt tensioners hav e been triggered. Imp ortant information – see page 51.

Pict ure no: 12944h.tif

Control i nd icator v for bel t tensioners Belt tensioners are m onitored electronica lly tog ether with the airbag system s and their op erational sta tus is shown by control indica tor v in the instrument panel. When the ignition is switched on, the control indica tor flashes for a pprox. 4 seconds. If it does not flash, does not go out after 4 second s, or illuminates w hile driving, there is a fault in the belt tensioning system or in the airbag sy stems, see page 57. The belt tensioners or airbag sy stems may fail to deploy in the event of an a ccident. Deploym ent of the belt tensioners is indica ted b y continuous illum ination of v.

Safety systems Im portant z Do not fit ac cessories not spec ifically released for your vehicle type or store ob jects in the belt tensioner operating area due to the risk of injury in the event the belt tensioners are triggered. z Do not m ake any modifications to the com ponents of the belt tensioners, a s this will render the vehic le unroadw orthy.

9 Warning Improper handling (e.g. removal or installation) c an activate the belt tensioners – risk of injury.

z The belt tensioner and airbag system control electronics can be found in the centre console area . In order to avoid malfunctions, d o not store magnetic objec ts in this area. z We recommend that you have the front seats removed by a Va ux ha ll Authorised Repairer. z The belt tensioners only actuate once. Please replace belt tensioners that have been trig gered. We recommend that you consult y our Vauxhall Authorised Repairer. z Applicable safety directives must alwa ys be observed when disposing of the vehicle. For this reason, disposal should be p erform ed by an authorised recy cling compa ny . We recommend that you consult y our Vauxhall Authorised Repairer.

53

54

Safety systems

Pi cture no: 12935h.tif

Using the belts

Fitting seat bel ts Pull the belt out of the retractor and guide it across the body , making certain that it is not twisted. Insert the la tch plate into the buckle. The back rest must not be tilted too far back, since this would affect the opera tion of the seat b elts; recom mended tilting angle approx. 25 ° . The lap b elt must be straight and lie snugly against the body. Tighten the la p belt at frequent intervals whilst driving by tugging the diagona l part of belt.

Picture no: 11178H.t if

9 Warning

O n pregna nt women in particular, the lap belt must be positioned a s low as possible across the pelvis so as not to put too much pressure on the abdomen. Bulk y clothing prevents the belt from fitting prop erly. The belt must not rest against ha rd or fragile objects in the pockets of your clothing (e.g. ballpoint pens, keys, spectacles) because these could cause injury. Do not place any objec ts (e.g. ha ndb ags, mobile phones) b etween the belt and your body.

Picture no: 12936h.tif

Height adjustm ent To adjust the height of front seat b elt upper anchora ge p oints: 1. Pull b elt out slig htly. 2. Pull k nob. 3. Set desired height. 4. Allow to loc k audibly into p osition. Do not adjust height while driving .

Safety systems

Pi cture no: 13461h.tif

Adjust height such that the belt p asses over the wearer’s shoulder and rests against the shoulder. It must not pass over the neck or upper arm.

Picture no: 11180H.t if

Rem oving t he b el t To remove the belt, d epress the red pushbutton on the buckle; the b elt will retract automatically.

55

Picture no: 15265h.tif

Three- point seat belt for centre rear seat Pull belt from roof m ounting by the latch plates. Click low er latch pla te into the ma tc hing (smaller) right b elt buckle. Use the upper latch plate to guide the belt ov er y our shoulder and stomach area without twisting it, click latch plate into the left outer b elt buckle. The latch plate of the central b elt only eng ages in the matching (left outer) belt buckle. The latch plate can be inserted in all the other belt buckles but w ill not eng age. 6

56

Safety systems

To remove the b elt, press the button on the left-hand buckle. The belt will retract automatically a nd will position itself ready to hand on the b ackrest. When enlarging the luggage compartment, disengag e the belt from both buckles; the belt will retract fully.

Picture no: 11181H.t if

Vauxhall Full Size airbag system The Vauxhall Full S ize a irb ag system comprises severa l ind ividual systems. Front a irbag system The front airb ag system is triggered in the event of a serious accident involving a frontal impa ct and forms sa fety cushions for the driver and front passenger 3. The forward movement of the driver a nd front passenger is check ed a nd the risk of injuries to the up per body and head thereby substantially reduced.

Picture no: 12947h.tif

Si de airba g system 3 The side airbag sy stem is triggered in the event of side-on collisions and forms sa fety cushions for the driver and front passenger in the respective front door area. The risk of injury to the upp er body in the event of a side impact is thereby substa ntially reduc ed.

Safety systems

57

Examples of events triggering the front airbag sy stem: z Impact against a non-y ielding obstacle: the front airbags are trigg ered at low vehicle speed. z Impact aga inst a y ielding obsta cle (such as another vehicle): the front airbags are only trigg ered at a hig her vehicle speed . 6

Picture n o: 15151H.tif

Pict ure no: 16184h.tif

Vauxhall Full Size airbag system

The front airb ag system will be trigg ered :

Front airb ag The front airbag system is identified by the word AI RBAG on the steering wheel and above the glov e c om partment 3.

z depending on the severity of the accident

The front airbag system comprises: z an airbag with inflator in the steering wheel a nd a second one behind the trim panel ab ov e the glove compartment 3 z the control elec tronics with impact sensor z the a irba g system s control indicator v in the instrument panel.

z depending on the type of impact z within the ra ng e shown in the illustration z indep endently of the side airb ag system 3.

58

Safety systems

9 Warnin g The three-point seat belt must b e correctly fitted – see pag e 55. The front airbag sy stem will not be triggered in the ev ent of z the ignition being switched off, z minor frontal collisions, z accidents in which the vehicle overturns, z collisions involving a sid e or rear impac t that is to say, if it w ould not be of benefit to the oc cup ants.

Picture n o: 11181H.tif

When trigg ered , the front airbags inflate in milliseconds and form a safety cushion for driver and front pa ssenger 3. The forward movement of the driver and front passenger is checked and the risk of injuries to the upper body a nd head thereby substantially reduced. No im pairment of view will occur, because the a irb ags inflate and deflate so quickly .

Pict ure no: 13473h.tif

9 Warning

The front airbag sy stem provides optimum p rotection when the seat, back rest a nd head restraint are correctly adjusted: adjust the driver’ s seat according to the occupant’s height suc h that with the driver sitting upright the steering wheel is held in the a rea of its upper sp ok es with the d riv er’s arms slightly bent. The passenger seat should be as far back as possible, with the back rest upright – see page 39. Do not place the head, body, hands or feet on the covers of the airba g systems. Do not place any objects in the area in which the airb ags inflate. Im portant inform ation – see page 61.

Safety systems

Pi cture no: 13461h.tif

9 Warning

Seat belts m ust therefore a lways be worn. The front a irb ag system serv es to supplement the three-point seat belts. If you do not wea r your seat belt you risk being seriously injured, or even thrown from the vehic le, in the ev ent of an accident. In the event of an ac cident the belt helps to keep you in the correct seating position, so tha t the front airbag system can provid e you with effective p rotection.

Pict ure no: 12945h.tif

Side airb ag 3 The side a irb ag system is identified by the word AIRBAG on the outb oa rd sides of the front seat backrests. The side a irb ag system c om prises: z an airbag with infla tor in the back of the driver’s and front passenger’s seat respectively , z the control electronics, z the side impact sensors, z the airbag systems c ontrol indicator v in the instrum ent panel,

59

Picture no: 12946h.tif

The side airbag sy stem will be triggered: z depending on the sev erity of the accident, z depending on the ty pe of im pact, z within the range shown in the illustration on the centre d oor pillar of the driver’s or front passenger’ s side, z ind epend ently of the front airbag sy stem. 6

60

Safety systems

9 Warning There must be no objects in the area in which the airb ag inflates or in the a rea between the seat backs and the vehicle body . Do not place the hand s or arms on the covers of the airba g systems. Imp ortant information – see page 61. The three-point sea t b elt must a lw ays be correctly fitted – see page 54. The side airba gs will not be triggered in the event of

Pi cture no: 12947h.tif

When triggered, the sid e airbag inflates in milliseconds to form a safety cushion for the d riv er or front passenger in the respective door area. This substantially red uces the risk of injury to the upper body in the event of a sid e-on collision.

z the ig nition being sw itched off, z fronta l collisions, z accidents in which the v ehicle overturns, z collisions involving a rear impac t, z collisions involving a side imp act outside the passenger cell. Control i nd icator v for airbag systems The airbag sy stems are m onitored electronically tog ether w ith the belt tensioners and their operational status is indica ted b y control ind icator v in the instrument panel. When the ignition is switched on, the control indicator flashes for a pprox. 4 seconds.

Picture no: 12944h.tif

If it does not fla sh, d oes not go out after 4 second s or illumina tes while driving, there is a fault in the airbag systems or the belt tensioner system see page 51. There is a possibility that the system s will not be triggered in the ev ent of an accid ent. Deployed airbag system s are indicated throug h constant illum ina tion of v,

9 Warnin g Have the cause of the fault remedied. We recommend that you consult your Vauxhall Authorised Repairer. The sy stem’s integrated self-diagnostics allows faults to be quickly remedied. Have y our C ar Pass on hand when consulting a Vauxhall Authorised Repairer.

Safety systems Im portant z Acc essories and other objects must not be affixed or placed in the a rea in which the airbags inflate a s they could cause injury if the airbags are dep loy ed. z Do not p la ce a ny objects between the airb ag systems and the vehicle occ upa nts; d ang er of injury .

9 Warning As with any other object, child restaint system s must not be carried on a passenger’s lap. Da ng er to life. z The electronics controlling the airbag system s and belt tensioners are located in the centre console. To prev ent malfunction, do not place any magnetic ob jects in the vicinity of this console. z Use the hooks 3 in the roof frame only to hang up light articles of clothing or c oa t hangers. Do not place any objects in the pockets of the hanging items – risk of injury.

z Do not stic k anything on the steering wheel, instrum ent panel or front seat back rests in the vicinity of the airbags or cover them with other materia ls. z Use only a dry cloth or interior cleaner to clean the steering wheel, instrument panel and front seat back rests. Do not use ab ra sive cleaning agents. z O nly protective covers whic h are approved for y our Agila with side airbags 3 may be fitted on the front seats. When fitting the protective covers, mak e sure that the airbag units on the outboard sides of the front seat back rests a re not covered. z The airb ag systems are triggered indep endently of each other based on the sev erity of the accident and the ty pe of impac t. z Each airbag can be trig gered only once. O nc e triggered, an airbag must be rep laced without delay. We recomm end that you consult your Vauxhall Authorised Repairer. z The speeds, d irections of m ov ement and deform ation p roperties of the v ehicles, and the properties of the obstac le concerned, determine the severity of the accident and triggering of the airbags. The degree of da mage to your vehic le and the resulting repair costs alone are not indicative tha t the criteria for triggering of the airbags were m et.

61

z Do not perform any alterations on the components of the airbag sy stem, as this would render the vehicle unroadworthy.

9 Warnin g The systems can b e triggered abrup tly and cause injury if they are ha nd led improperly. z We recom mend entrusting removal of the steering wheel, the instrument pa nel, the front seats a nd the seat b elts to your Vauxhall Authorised Repairer. z Applicable safety directives must always be ob served when disposing of the vehicle. For this reason, d isposal should be performed by an authorised recycling company. We recommend that you consult your Vauxhall Authorised Repairer. z Any one weig hing less than 35 kg should sit in the rear seats.

62

Safety systems Mounting brackets 3 for ISOFIX child restraint systems Mountings 3 for the attachment of IS OFIX child restraint system s are located betw een the backrest and seat cushions of the outboard rear seats. The instructions a ccompanying the IS OFIX child restraint system are to be expressly followed. O nly ISO FIX child restraint sy stems app rov ed for the v ehicle m ay be used. We recommend that y ou consult y our Vauxhall Authorised Repa irer.

Picture no: 11704a.tif

Use of child restraint systems 3

9 Warning Child restraint sy stems must not b e installed on the front p assenger seat of any v ehicle with airbag systems 3 - risk to life. If the vehic le is equipped with airba g system s, child restraint sy stems must be mounted on the outboard sea ts in the rear seat row 3. Child restraint sy stems may only be installed on the front p assenger seat if the vehic le is not equipped with airba g system s.

Pict ure no: 12945h.tif

Vehicles with a front passeng er airbag 3 can be identified by the word AIR BAG above the glove compa rtm ent and – with the passenger door op en – the warning sticker on the side of the dashboard. S ee Fig. 11704 A. Vehicles with side airbag s 3 can be identified b y the word AIRBAG on the outboard side of the front seat ba ckrest. See Fig. 12965 H.

Safety systems Child restraint system

3 The Vauxhall child restraint system is designed specifica lly for y our Va ux ha ll and thus prov ides optimum safety for your child in the event of im pact. I f a different child safety seat is used, follow the manufacturers’ instructions for fitting and use. The country in which you are d riv ing could req uire the use of c hild restraint system s and specific seats. Follow a ll loc al and nationa l regulations.

Selec ting the rig ht system Your child should be transported facing rearward in the car as long as possible. Change the sy stem when the height of the child is such that the head ex tends over the top of the system and is no longer supported at ey e level. The child’s cervical vertebrae are still very weak. In the event of an accident, they are subjected to less stress in the sem i-prone rea rw ard position than w hen upright.

63

Not e z Children under 12 yea rs or under 150 cm tall should only trav el in an ap prop ria te child sa fety sea t. z When transporting c hildren, use the child restra int system s suitable for the child’s weight. z Ensure correct installation of c hild restra int system , see the instructions enclosed with the sy stem.

9 Warning

z The covers of the Vauxhall child restraint sy stem can b e wiped clean.

C hild restaint sy stems must not be carried on a p assenger’s lap. Danger to life.

z Do not stick any thing on the child restra int systems and do not cover them with any other m aterials. z Only allow child ren to enter and exit at the side fa cing away from the traffic. z A child restraint sy stem which has been subjected to stress in an accident must be replaced.

64

Safety systems X = No child restraint system permitted.

Permissible opti ons for fi tting a child safety sea t Weight and age cl ass1 )

0: up to 10 kg or approx. 10 months

On front pa ssenger sea t of v ehi cle with a irbag system s

On front passeng er seat of vehicle without airb ag systems

On out er seats in rea r row

On cent re seat in rear row

X

U

U+

X

X

U

U+

X

X

U

U

X

0+: up to 13 kg or approx. 2 years I: 9 to 18 k g or approx. 8 months to 4 years II : 15 t o 25 kg or approx. 3 to 7 years II I: 22 t o 36 kg or approx. 6 to 12 y ears

1)

We reco mmen d the use of each system u ntil the child reaches the up per weight lim it.

U = Universal suitability in conjunction with three-point seat belt. +

= Seat with IS OFIX mounting availab le. When mounting with ISO FIX, only IS OFIX child restraint systems that have been approved for the vehicle m ay b e used. We recom mend y our Vauxhall Authorised Repairer.

Safety systems Head restraints

Safety accessories 3

Ad just the head restraints to suit body size 3. See pa ge 39.

The wide ra nge of Vauxhall accessories allows you to equip your Agila in acc orda nce with your own wishes. In add ition to safety accessories, item s for improving comfort a nd a complete ra nge of vehicle care p roducts you will find m any articles w hich w ill be of g reat va lue to you when need ed.

Do not m ount any objects or components not specific ally released for y our Agila on the head restraint. They would hinder the protective function of the head restraint and could be thrown uncontrollab ly through the v ehicle in the event of hea vy braking or an acc id ent.

Sun visors, glove com partment Pi cture no: 13481h.tif

Exterio r mirrors

For the safety of pedestrians, the exterior mirrors will swing out of their normal mounting p osition if they are bumped with sufficient force. Reposition the m irror by apply ing slight pressure to the mirror housing.

65

The mirror cover in the sun visor a nd the glove compartment should be closed whilst driving.

"Genuine Vaux hall Parts a nd Accessories" guarantee high quality a nd accurate fit. Y our Vauxhall Authorised Repa irer will be happy to advise you, for ex ample with regard to: z Vauxhall child restra int system s, z Tow ropes, z Tow rods, z Jump leads, z Spare bulb kit, z Spare fuse kit, z Halogen fog lights, z Mud flaps, z Magnetic lig ht, z Wa rning triangle, z First-aid kit, z First-aid kit (cushion).

66

Ligh ting

Lighting

Vehicles with d aytime running lights 3: With the ignition on and the light switch on 7, dipped beam without instrument illum ination is on. The day time running lights switch off when the ignition is switched off. Follow the regula tions of the country in which you are driving w hen using da ytime running lig hts and fog lights 3. Driving ab road – see pag e 68.

Headlight range adjustment ? .... ..... . Fog lights > 3 ..... .... ..... .... ..... .... .... ..... . Fog tail light .... ..... .... ..... .... ..... .... .... ..... . Turn signals, hazard warning lights.. . Reversing lights.... .... ..... .... ..... .... .... ..... . Courtesy lig ht 0.. .... ..... .... ..... .... .... ..... . Instrument illum ination .... ..... .... .... ..... . Information display illumination 3.... . Ashtray illum ination 3 . .... ..... .... .... ..... . Headlights w hen driving abroad . ..... .

67 67 67 67 67 68 68 68 68 68

Pict ure no: 18156h.tif

Exterior lights Turn light switch: 7 8 9

= = =

O ff Parking lights Dipped beam, main beam

Dip ped beam , main b eam and head lig ht flash – see p age 10. In positions 8 and 9, the tail lights and numb er plate light are also illuminated. If the ignition is switched off while dipp ed beam or main beam is on, the parking lig hts come on 3.

Lightin g

67

Fog tail light On = O ff =

Press r, r illuminates in instrument panel Press r again or switch ignition or light off

The fog tail light can only be switched on, when the ignition and dipped beam/ park ing lig hts are on. The fog tail lights on the vehicle are deactivated when towing a caravan/ trailer.

Pi cture no: 18157h.tif

Headlight range adju stment

? Adjust headlight range to four stages of vehic le load ing with dipped beam switched on: turn knurled wheel to d esired position. Correct adjustment of the headlight range red uces dazzle for other road users. z Front seats occupied

= 0

z All seats occ upied

= 1

z All seats occ upied and lugga ge c om partment load

= 2

z Driv er’s seat occupied and lugga ge c om partment load

= 3

Pict ure no: 11457h.tif

Turn sign als, hazard warning lights

Fog lights

see page 11.

On =

Reversing lights

Off =

>3 Press >, > illuminates in instrum ent panel Press > ag ain or switch ignition or light off

The fog lights can only be switc hed on when both the ig nition and lights are on.

C om e on when reverse gear is engaged and ig nition is sw itched on.

68

Ligh ting Instrument illumination C om es on together with ex terior lighting (not when da ytime running lights are on 3).

Information display illumination 3 C om es on when the ignition or infota inm ent system is on.

Ashtray illumination

3 C om es on together with ex terior lighting.

Picture n o: 11186H.tif

Courtesy light

0 Com es on when a door is opened.

Pict ure no: 11458h.tif

To k eep the courtesy light on, p ull the light switch.

Headlights when driving abroad The asy mmetrica l dipped beam increa ses the field of vision on the passenger side of the lane. This causes g la re for oncom ing traffic if the vehicle is driven in countries where traffic drives on the opposite side of the road. To av oid glare, place masking strip s on both hea dlights. We recomm end that y ou consult your Vauxhall Authorised Repa irer.

Windo ws, Su n roof

Windows, Sun roof

9 Warning Take care when operating the electric windows 3. Risk of injury, particula rly to children. Vehicle passeng ers should be inform ed accordingly. K eep a close watch on the windows when closing them. Ensure that nothing becomes trapped in them as they move.

Electric windows in front d oors 3 . ..... . Sun roof 3 ... .... ..... .... ..... .... ..... .... .... ..... .

70 71

Before lea ving the v ehicle, remove the ignition key in order to p revent unauthorized opera tion of the wind ow s and sun roof.

Picture no: 11188H.tif

Do or windows

Turn the hand crank clockwise or anticlockwise

69

70

Windo ws, Sun roof To op en: To op en completely , hold the b utton depressed until the window fully rea ches its end position. To op en in stages, p ress the button b riefly. To close: To close completely, hold the button depressed until the window is completely closed. To close in stag es, press the button briefly .

Picture n o: 11189H.tif

Electric windo ws in front doors 3

O perated via tw o roc ker switches in the driver’s door ha nd le - one for the driver’s door window and one for the passenger door window. Ad ditional rocker switch in the p assenger door handle.

Windo ws, Su n roof

71

To close: Turn crank to rig ht. When the crank will not turn any further the sun roof has reached the comfort position. Press unlocking button aga in and continue to turn crank to rig ht until sun roof is closed. The unlock ing button is automatically relea sed when the sun roof rea ches the closed position. To raise: Close sun roof a nd p ress unloc king button. Turn crank to rig ht.

Picture n o: 11190H.tif

Sun roof 3

Tilt crank out of rec ess. To open: Press unlocking b utton. Turn crank to left. When the crank will not turn any further the sun roof ha s reached the comfort position, and air noise w ill be reduced . To open beyond the comfort position: press unlock ing button a gain. Continue to turn crank to the left.

To lower: Turn crank to left. The unlock ing button is automatically relea sed when the sun roof rea ches the closed position. After operating the sun roof, a lw ays return the crank to the recess.

Picture no: 11191H.tif

Sun shad e The sun sha de c an be op ened and closed with the sun roof either closed or raised. When the sun roof is opened, the sun sha de is also opened.

72

Climate c ontrol

Climate control

Air vents .. .... .... ..... .... ..... .... ..... .... .... ..... . Air recirculation system .... ..... .... .... ..... . Heated rear window Ü.... ..... .... .... ..... . Heating and ventila tion system ... ..... . Air conditioning system 3 ..... .... .... ..... . Air intake . .... .... ..... .... ..... .... ..... .... .... ..... . Air outlet.. .... .... ..... .... ..... .... ..... .... .... ..... . Pollen filter 3 ... ..... .... ..... .... ..... .... .... ..... . Note .... ..... .... .... ..... .... ..... .... ..... .... .... ..... . Maintenance ... ..... .... ..... .... ..... .... .... ..... .

73 74 74 75 78 80 80 80 80 81

Picture no: 11200H.t if

Heating and ventilation system, air conditioning system 3 Ventilation, heating and cooling 3 a re combined into one unit that is d esigned to prov ide com fort regardless of the season, weather or outside temperature. When cooling 3 is activated, the air is cooled and dried. The heating unit heats the air a s required in all operating m od es depending on the position of the temperature switch. The air supply can be adjusted to suit requirements by means of the fan. The slid er for the air recirculation sy stem can be used to block the air supply from outside.

Picture no: 11202H.tif

Button n for cooling (in temperature rotary switch) is only found on v ehicles equipped with the optional air conditioning system 3. S ee page 78.

Climate control

Pi cture no: 16185h.tif

Air vents

Pleasant ventilation of the head a rea is achiev ed, depending on the p osition of the tem perature switch a nd the air distrib ution switch (L or M). To increase the air supply, set the fan to a higher speed a nd set the a ir distribution switch to M. Centre and sid e air vents (1) The a ir flow can be directed as desired by tilting and swivelling the sla ts.

Pict ure no: 11459h.tif

Open side vents: Turn k nurled wheel cloc kwise. To close the side vents, turn knurled wheel anticlock wise.

73

Picture no: 11460h.tif

Windscreen defrost er nozzles (2) Air distribution switch set to V or J: Air is directed onto the wind screen and the door windows. Ad ditional vents Located in front of the windscreen, in front of the door wind ow s a nd in the front footwell.

74

Climate c ontrol General in formation , as well as info rm ation on air intake, air ou tlet, pollen filter and main tenance, see pages 80, 81.

Picture n o: 11195H.tif

Picture no: 11125H.t if

Air recirculation system

Heated rear window Ü

To act ivat e: Push slider to left 4, air supply from the outside is blocked.

Operating using the fan switch:

If fumes or unpleasant odours penetra te from outside: tem porarily sw itc h on the air recirculation system. To circulate the passenger c om partment air, switch on the fan too.

Symb ol illuminates when heated rear wind ow is switched on.

The a ir recirculation sy stem minimises the entry of outside air. The humidity increases, and the windows can m ist up. The quality of the passenger compa rtm ent air deteriorates which ma y cause the vehic le occupants to feel drowsy. To deacti vate: Push slider to right 5, air is fed in from the outside a gain.

On Off

= =

Pull fan sw itch Ü Press fan sw itch Ü

Heating operationa l only with engine running. Switch off as soon as rear vision is clear.

Climate control

Picture n o: 11192H.tif

Heatin g and ventilation system Left -hand rota ry swit ch: Temperature red zone = warm blue zone = cold

Picture no: 11193H.t if

Centre rotary switch: Quanti ty of a ir Four fan speeds: x O ff 4 Max imum air flow The rate of air flow is determined b y the fa n. The fan should therefore a lso be switched on during a journey.

Picture no: 11194H.tif

75

Rig ht-hand rot ary swi tch: Air distribut ion K to foot well J

to windscreen, front door windows and to foot well

V

to windscreen and front door windows

M

to head area

L

to head area and footwell,

O pen the air vents when the switch is set to L or M.

76

Climate c ontrol Hea ting The amount of heat is dependent on the engine temperature and is thus not fully attained until the engine is warm. For rapid warming of the p assenger compartment: z Set the temperature switch in the red zone. z Set the fan to speed 3. z Set the air distribution sw itch to the desired position – see page 75.

Picture n o: 11200H.tif

Vent ilation z Set temperature switch to desired setting. z Switch fan on at desired setting. z For max imum ventilation in head area: Set air distrib ution sw itc h to M a nd open all vents. z For ventila tion to foot well: Set air distribution switch to K . z For simultaneous ventilation to the hea d area a nd the foot well: Set air distribution switch to L .

The c om fort and general well-being of the vehicle occupants are to a large extent dependent on a suitab le v entilation a nd hea ting setting.

Climate control

77

z Turn the temp erature switch as far into the red zone a s p ossible, z Set fa n to 3 or 4, z Set air distribution switch to V, z Open sid e air vents as required and direct them towards door windows, z Switch on heated rear window Ü, z For simultaneous warming of the foot well, set air distribution switch to J.

Picture n o: 11201H.tif

Heating the foot well z Set the tem perature switch in the red zone. z Switch on fan. z Set air distribution sw itch to K. z Keep side air vents closed during the warming-up phase.

Picture no: 11126H.t if

Dem ist ing and defr ost ing the windows

9 Warning

Failure to follow the instructions could lead to misted or icy windows and accidents stemming from impa ired visibility.

78

Climate c ontrol

Air conditioning system

3 As a supplement to the heating and ventilation system, the air c onditioning system c ools and dehumidifies (dries) inflowing air. If cooling or dehum id ification is not desired, switch off cooling in order to sa ve fuel. At low outside tempera tures the cooling unit (air conditioning compressor) switches off autom atically.

Pict ure no: 12986h.tif

Cooling n Operational only when eng ine is running. On = Pull temp erature switch n Off = Press temp erature switch n

Picture no: 13482h.tif

C omfort setting z Move air recirculation slid er to right 5. z Activate cooling n as desired.

Control indica tor in p ushbutton.

z Set temperature switch to desired setting.

Set the fan to the d esired setting.

z Set fa n to desired speed . z Set air distribution switch to M or L. z Open sid e air vents as required .

Climate control

79

z Move air recirculation slid er to right 5. z Cooling on: pull n, z Set temperature switch to desired setting, z Set fa n to desired speed , z Set air distribution switch to V

Picture n o: 11203H.tif

Maximum cooling O pen windows and sun roof 3 briefly so that warm air can escap e rapidly . z Move air recirculation slid er to left 4. z Cooling on: pull n. z Turn the temperature switch as far into the blue zone (cold) as possible. z Set fan to 4. z Set air distribution sw itch to M. z Open all vents.

Pict ure no: 11461h.tif

Dem ist ing and defr ost ing wind ow s

9 Warning

Failure to follow the instructions could lead to misted or icy windows and accidents stemming from impa ired visibility. Misted or icy windows, e. g. due to damp weather, damp clothing or low outside temperatures:

– or – if there is still m oisture in the system after previous air conditioning operation, the windows may m ist up. To prev ent this, set air distribution to K before starting engine a nd set to V app rox . 5 seconds after starting. z Switch on heated rear window Ü. O peration with cooling (air conditioning compressor) is not possible w hen outside temperatures a re low.

80

Climate c ontrol Pollen filter

Picture n o: 11196H.tif

Air intake

The air intakes in front of the wind screen on the far left and right-hand sides of the engine compartment must be k ept free of lea ves, d irt and snow.

Air outlet When transporting objects in the luggage compartment, m ake sure the air outlets are not covered.

3 The pollen filter cleans the air entering from outside, or if the air circulation sy stem 3 is switched on, filtering dust, soot, p ollen and spores out of the interior air.

Note

The pollen filter must b e replaced at the intervals specified in the Service Booklet.

The cooling system (air conditioning compressor) only opera tes when the eng ine is running.

If the windsc reen m ists up during dam p weather conditions, set the system as desc ribed under "Wind ow dem isting". See pag es 77, 79.

C ooling 3 functions most efficiently when the wind ow s a nd sun roof 3 are closed. If the passenger compa rtm ent has heated up considerably after a long period in direct sunlight, briefly open the windows and sun roof 3 so that the hot air can esca pe q uick ly .

Climate control When cooling 3 (air c onditioning compressor) is switched on condensation forms, which is ex pelled from the underside of the v ehicle. At lea st one air vent must b e open while cooling 3 (air conditioning compressor) is on in order to prevent the evaporator from icing up due to lack of air movement.

Maintenance In order to ensure consistently good op eration, the air cond itioning compressor 3 must be switched on for several minutes once per month irresp ective of the wea ther or tim e of year. Operation with cooling (air c onditioning compressor) 3 is not possible when outside temperatures are low . In the event of a fault, consult a w ork shop. We rec om mend your Vauxhall Authorised Repairer.

81

82

Drivin g Hints

Driving Hints

The first 600 miles Driv e y our v ehicle at various speed s. Do not use full throttle. Never allow the engine to labour at low rev s. Make good use of all gears. In all g ears depress the acc elera tor pedal a m aximum of around three quarters of the available pedal tra vel. Do not d riv e faster than three quarters of maximum speed . Do not b rake unnec essarily ha rd for the first 125 miles.

Never coast with engine not run ning Many units w ill not function in this situation (e.g. brake servo unit, power steering 3 ). Driv ing in this ma nner is a danger to yourself and others.

Brake servo unit When the engine is not running, the brake servo unit is no longer effective once the brake peda l has been depressed once or twice. Braking effect is not reduced , but significantly greater force is required for braking.

Electric po wer steering 3 If the power-assisted steering fails when being towed with the engine switched off, the vehicle can still be steered, but considera bly more forc e is req uired.

Driving in mo untainous terrain or with a trailer/caravan The cooling fan is electrically operated. Its cooling power is therefore independent of the engine speed. S ince a c onsiderab le am ount of heat is generated at high engine speeds and less at slower speeds, do not shift down when climb ing hills whilst the vehic le is still coping with the gradient in the hig her gear.

Driving with a roof load Do not exceed the perm issible roof load and m aximum loa ding height, see pag es 102, 150. For reasons of safety, distribute the loa d ev enly a nd secure it properly with reta ining straps so that it cannot slip . Adjust the tyre pressure to suit the load. Do not drive faster than 75 mp h. Chec k and retighten the straps freq uently .

Switching off the engin e When y ou switch off, fans in the eng ine compa rtm ent may continue running for a time to cool the engine. If the engine temperature is very high, e.g. after driving in mountainous terrain: allow the engine to id le for approx im ately two minutes in order to prevent heat acc um ulation.

Driving Hints Vehi cles w ith turb ocharged engine After running at hig h engine speeds or high engine loads, opera te the engine briefly at a low load or run in neutral for approx. 30 sec onds before switching off in order to protect the turbocha rger.

Save energy – mo re miles Please observe the running-in hints on the previous pag e and the tips for energ y saving on the following pages. Good, technica lly correct and economical driving ensures ma ximum durability and performance for your vehic le.

Overrun The fuel supply is autom atically shut off during overrun, e.g. when the vehicle is being driven down long gradients or when braking. To enable the overrun cut-off to take effect, do not acc elerate during overrun and do not de-clutch. To prevent dam age to the cata ly tic converter, overrun cut-off is temp orarily deactivated when the cataly tic conv erter temperature is high. Vehi cles w ith turb ocharged engine Flow -g enerated noises may be aud ible if the a ccelerator is released quickly due to air flow in the turbocharger.

83

Engine speed

Pedals

Driv e in a low engine speed range for each gear a s m uc h as possible.

Do not place any ob jects in the foot well which could slip under the ped als and inhibit the pedal trav el.

Warm ing up Allow the engine to warm up while driving. Do not warm it up by letting it run at idling speed. Do not apply full throttle until the engine has reached op erating temperature.

Correct gear selection Do not race your engine whilst in neutral or with a low gea r selected. Driving too fast in indiv idua l gea rs as well as stop-a nd -g o tra ffic increase eng ine wear and fuel consumption.

Change down When decreasing speed, shift down into the next lowest gear. Do not slip the clutch with a high-revving engine. This is especially important when hill climb ing.

Clutch operation Alw ays dep ress the clutch ped al hard to the floor to prev ent shifting difficulties and tra nsmission dam age. When driving do not use the pedal as a foot rest; this will ca use substantial clutch wear.

To ensure the pedal travel is uninhibited, there must be no mats in the area of the pedals.

Battery c are When driving slowly or when the v ehicle is stationary , e.g. in slow urban traffic, stopand-go traffic or traffic jams, turn off all unnecessary electrical load s w here possible (e. g. heated rear window, auxiliary headlights, etc.). Declutch w hen sta rting in order to relieve the strain on the starter and the ba ttery.

84

Saving fuel, Protectin g the environment

Saving fuel, Protecting the environment

New painting techniques employ wa ter as a solv ent.

End-o f-life vehic le reco very For detailed information on Va ux ha ll’ s on-going comm itment to achieving an environmentally susta inab le future, including; design for recycling, take back of End-of-Life Vehicle (ELVs) a nd the recycling of ELVs, view www.va ux ha ll. co.uk/recycling for details.

Energy and environmentconscio us driving

Trend-setting technology When dev eloping and manufac turing your vehic le, Vauxhall used environmentfriendly and pred om inantly recyc la ble materials. The production methods used to mak e y our v ehicle are likewise env ironmenta lly -compatible. Recycling of production wastes keeps the circulation of material closed. Reduction of energy a nd water requirements a lso help s to conserve natural resources. A highly adv anced design mea ns that your vehic le can be easily disassembled at the end of its serv ic e life, and the ind ividual materials separated for subsequent re-use. Materia ls such as asbestos and cadmium are not used . The refrigerant in the air conditioning system 3 is C FC -free.

z High noise levels and exhaust em issions are often a result of driving w ithout due attention to saving energy and protecting the environment. z Y ou should therefore drive with energy in mind – "more miles with less fuel" . Reduce the noise level and exhaust emissions b y adopting an environmentconsc ious driving style. This is ex tremely worthwhile and im proves the quality of life. Fuel consum ption d epend s to a great extent on your own personal d riv ing style. The follow ing hints will help you to achieve fuel consumption as close as possible to the specified levels – see pages 148 to 149. C heck y our v ehicle’ s fuel consumption every time you refuel. This facilitates early detection of any irregula rities causing increased fuel consumption.

Warming up z Full throttle and w arming up at idle speed increase w ear, fuel consumption, ex haust em ission, the am ount of pollutant in the exhaust and the am ount of noise. z Driv e off imm ediately after starting. Wa rm up the engine b y running it at moderate eng ine speeds.

Uniform speed z Hectic driving significantly increases fuel consumption, the ex haust emissions, the proportion of pollutant in the exhaust gas and the noise level. z Do not accelerate a nd brake unnecessarily . Drive at uniform speed, watching the road. Avoid frequent starting off and stopping e.g . at traffic lights, in short distance tra ffic and in queues of traffic by m eans of clever planning . Select road s w ith good traffic flow .

Idling z The eng ine also consumes fuel when idling . z If you have to wait for more than one minute, it is worthwhile switching off the engine. Fiv e m inutes of idling corresponds to ap prox imately one 0.6 miles of driving.

Saving fuel, Protecting the environment Overrun z The fuel supply is automatically shut off during ov errun, e. g. when the vehicle is being driven down long gradients or when braking – see page 83. z To enable the overrun cut-off to come into action and sav e fuel, do not accelerate or d eclutch during overrun.

Correct gear selection z High revs increase engine w ear and fuel consumption. z Do not race your engine. Avoid d riv ing at high engine speeds. Making use of the tac hometer 3 helps to save fuel. Drive in a low engine speed ra nge for each gear as much a s possible with uniform engine speeds. Drive as often as possible in top gear, select the next higher gear a s soon as possible, and only chang e down when the engine is no longer running perfectly smoothly .

High speed z The higher the speed , the higher the consumption and the noise level. At top speed, you consume a great deal of fuel and produce excessive noise and exhaust em issions.

z Slightly relea sing the accelerator ped al results in distinct fuel savings with no major loss of speed. Drive at no more tha n around three quarters of max imum speed and you will use up to 50 % less fuel, without losing a great deal of time.

Tyre pressure z Inadequate ty re p ressure, leading to higher road resistance, costs m oney in two wa ys: for more fuel and increased tyre wear. z Regular checks (every 14 d ays) pay off.

Electrical loads z The power consum ption of electrical equip ment increa ses fuel consumption. z Sw itch off all aux iliary electrical loads (e. g. air c onditioning 3, heated rear window) when not needed.

Roof racks z Due to air resistance, a roof load can increase fuel consump tion by approx. 3.5 gals/h. z Remove them if they are not being used.

85

Repair and maintenanc e z Improper repairs or adjustm ent and maintenance work can increase fuel consumption. Do not carry out w ork on the eng ine yourself. You may out of ignorance infringe environmental law s b y not disposing of materials properly. Appropriate parts might not b e recycled. Contact with some of the materia ls inv olv ed may p ose a hea lth haz ard. z We recom mend that repair and maintenance be entrusted to your Vauxhall Authorised Repairer.

Extreme drivin g conditions z Going up steep slopes, cornering, driving on poor road s a nd winter driving a ll increase fuel consumption. z Fuel consumption increa ses dramatically in urba n tra ffic a nd at winter temperatures, especially on short trip s when the engine operating tempera ture is not reached. z Follow the hints given above to keep consumption to a m inimum under suc h cond itions.

86

Fuel c onsum ption, fuel, refuelling

Fuel consumption, fuel, refuelling

Fuel c onsum ption

Fuel for petrol engines

Fuel consumption is determined under specific driving conditions – see page 148.

C om mercially availab le high-quality fuel with a maximum ethanol content of 5% as per DIN EN 228 (catalytic c onverter - see pag e 88, octane numbers - see page 146). Fuel quality ha s a dec isive influenc e on power outp ut, running behaviour and service life of the engine. The additives contained in the fuel pla y an important role in this regard. You should therefore only use high-quality fuels containing additives.

Fitting special equipment will increase the weight of the vehicle. This in turn increases fuel consumption and reduces the specified m aximum speed of the vehicle. For the first few thousand miles, friction between the engine and transmission components is higher. This increases fuel consumption.

Fuel consump tion .... ..... .... ..... .... .... ..... . Fuel for petrol engines . .... ..... .... .... ..... . Fuel filler ca p... ..... .... ..... .... ..... .... .... ..... . Refuelling . .... .... ..... .... ..... .... ..... .... .... ..... .

86 86 87 87

Fuels with ethanol content greater than 5% do not comp ly with DIN EN 228 and m ust not be used unless the vehicle has been spec ifically dev eloped and ap prov ed for use of such. Fuel with too low an octane number can cause ping ing. Va ux ha ll cannot b e held liable for resulting damage. Petrol with a hig her octane number can alway s be used . Pump nozzles for leaded fuel ca nnot be inserted into the filler nec k of vehicles tha t operate on unlead ed fuel. The ignition timing is automatically adjusted according to the grad e of fuel used (octane num ber) – see page 146. Use of petrol with an octane rating of 95 will ensure economical driv ing.

Fuel consumption , fuel, refuellin g Fuel filler cap If the fuel filler cap must be replaced, use only the Genuine Vauxhall fuel filler c ap designed for y our model to ensure that full func tionality is retained. Vehicles with diesel engine ha ve a sp ecial fuel filler cap.

Refuelling

9 Warning Care must b e tak en when ha ndling fuel. Before refuelling , switch off engine a nd any ex ternal hea ters with combustion cha mbers before refuelling. Switch mobile phones off. Fuel is flamm able and ex plosive. a void nak ed flam es or sparks when handling fuel or just in its vicinity. Do not smoke. This a lso applies where fuel is perceptible only from its c harac teristic od our. If fuel od ours occur in the v ehicle itself, eliminate the cause im media tely. We recommend your Vux hall Authorised Repairer.

87

The fuel tank filler neck with screw cap is loca ted on the left-hand side of the v ehicle in the rea r quarter panel. Open the tank flap . To op en, unlock the fuel filler cap with the ignition key 3 and carefully unscrew so that the excess pressure can slowly dissipate. Attac h filler ca p to bracket on flap and turn to secure. The fuel tank has a limiting sy stem which prevents ov erfilling of the tank.

Picture no: 12259h.tif

C orrect filling depends to a large extent on proper operation of the fuel disp ensing pump: 1. Fully insert the pump nozz le and switch it on. 2. After the autom atic cut-off, another two litres (ma x.) can be topp ed up in stages. To close, replace filler ca p and turn, overcoming the resistance, until the lock on the cap engages audibly . Lock filler ca p with ignition key 3. C lose fuel tank cov er. Wipe off any ov erflowing fuel immediately .

88

Catalytic converter, exhaust gases

Catalytic converter, exhaust gases

Ca ta lytic converter for petrol eng ines Controlling ex haust em ission.... .... ..... . Ex haust ga ses. ..... .... ..... .... ..... .... .... ..... . Maintenance ... ..... .... ..... .... ..... .... .... ..... .

Dama ge to the catalytic conv erter or the vehicle m ay result if the following points are not observed : z Consult a work shop, such as your Vauxhall Authorised Repairer, as quic kly as possible in the event of misfiring, irregular engine running following a cold start, a significant loss of engine power or other unusual malfunctions which may indica te a fa ult in the ignition sy stem. If necessary, d riv ing may be continued for a short time at a low speed and with a low engine speed.

88 89 90 91

Picture no: 6448U.tif

Catalytic converter for petrol engines Leaded fuel will da mage the cata ly tic conv erter and parts of the electronic sy stem, rend ering them inoperative. Use of high-qua lity fuels other than those specified on p age 86 (e. g. LRP 1)) c ould damage the catalytic converter. On vehicles with a c atalytic converter, the fuel ta nk filler nec k is of a narrow design so that a dispensing pump for leaded fuel cannot b e inserted .

1)

LR P = Lead Rep la cement Petrol.

z If unb urnt fuel enters the c atalytic conv erter, this may result in overheating and irreparable damage to the c atalytic conv erter. You should therefore av oid unnecessarily long use of the starter when starting off, running the tank dry (an irregular fuel supply w ill lead to overhea ting) and starting the engine by pushing or towing.

Catalytic converter, exhaust gases

89

z If emission c ontrol indicator Z flashes, slow down until the flashing stops and the control indicator shines with a stea dy glow . Contact a workshop im med ia tely. We recom mend y our Vauxhall Authorised Repairer – see Emission control indicator Z.

Pict ure no: 16178h.tif

Controlling exhaust em ission Through d esign-related measures – mainly in the area of the fuel-injection and ignition sy stems – the prop ortion of noxious materials in the exhaust, suc h as carbon monox ide (C O), hy drocarbons (HC ) and nitrogen oxides (NO x), is reduced to a minim um .

Picture no: 12948h.tif

C ont rol indic ator Z for exha ust gases Illuminates when ignition is switched on and during start attempt. Goes out shortly after engine starts. If it illuminates w hile the engine running there is a fault in the emission control system. The permitted emission values may be exceeded. C onsult a workshop imm ediately. We recomm end y our Vauxhall Authorised Repairer. Flashing with the engine running indica tes a fa ult that m ay da mage the cata ly tic converter. Y ou can continue to drive without causing dam age by slowing down until the flashing stops and the control indicator is steady. Consult a workshop imm ediately. We recomm end that y ou consult a n Vauxhall Authorised Repairer. 6

90

Catalytic converter, exhaust gases In some cases, the fault can be rem edied by switching the engine off and on again. If the control indic ator illuminates a gain when the engine is running, consult a work shop to have the cause of the fault remedied. We recommend your Vaux hall Authorised Repairer. If it illum ina tes briefly , but does not recur, it is of no significa nce. If it flashes after the ignition is switched on, there is a fa ult in the immobiliser system. The engine cannot be started – see page 29.

Pi cture no: 12943h.tif

Cont rol indica tor A for engi ne electronics Illuminates for a few seconds when the ignition is switched on. If it illum ina tes when the engine is running, there is a fault in the engine electronics system. The electronic s switch to limphome mode, fuel consum ption m ay increase and the driveability of the v ehicle may be impaired.

Exhaust gases

9 Warnin g Engine exhaust gases contain poisonous carbon monoxide, w hich is colourless and odourless and c ould b e fatal if inhaled. If ex haust fumes p enetrate the v ehicle interior, open the w indows and consult a workshop im mediately. We rec om mend your Vaux ha ll Authorised Repairer. When the vehicle is driven for the first time, wax and oil on the exhaust system m ay evaporate, prod uc ing smoke. After driving the vehicle for the first tim e, allow it to stand in open a ir to allow the fumes to evaporate and do not inhale.

Catalytic converter, exhaust gases Maintenanc e Hav e all maintenance work carried out at the interv als specified by Vauxhall. We recom mend that y ou entrust this work to your Vauxhall Authorised R epairer, who has proper equipment and trained personnel av ailable. Electronic testing systems permit rapid dia gnosis and rem edy of faults. This way you can be certa in that a ll comp onents of the vehicle’s electrical, injec tion and ignition systems opera te correc tly , that your vehicle has a low level of pollutant emission and that the cataly tic conv erter system will have a long service life.

You are thereby mak ing an important contribution towa rd s keep ing the air clean and compliance w ith emissions legislation. Check ing and adjustm ent of the fuelinjection and ignition system s is p art of the scope of inspection. For this rea son you should have all maintenance work c arried out at the interv als specified in your Service Book let.

91

92

Brakes

Brakes

Brake system The brakes are a n important factor for tra ffic safety . To improve effectiveness, do not brake unnec essarily ha rd for the first 120 miles (200 km) after new brak e p ads ha ve been fitted. Brake pad wear must not ex ceed a specified lim it. Reg ular maintenance as detailed in the S ervice Booklet is therefore of the utmost im porta nce for traffic sa fety.

Brake system ... ..... .... ..... .... ..... .... .... ..... . Anti-lock brake system (ABS u ) 3 ... .

92 94

Have worn brake pads replaced. We recommend that you consult your Vauxhall Authorised Repairer, who will fit pads that ha ve b een tested a nd approved by Vauxhall and guarantee optimum braking power. Brake pads that have worn down to the minim um thickness will squeal. Driv ing may be c ontinued. Have the b rake pads replaced as soon a s p ossible. Consult a work shop for brak e pa d replac ement. We recommend your Vauxhall Authorised Repairer.

Picture no: 11209H.t if

Foot bra ke The foot brak e comprises two independent brak e circuits. If a brak e circuit fails, the vehicle can still be brak ed using the other brak e circuit. If this occurs, howev er, the brake pedal must be depressed q uite far using considerab le force before braking effect occurs. The distance required for b ra king will be greater. Consult a work shop before continuing y our journey . We recommend y our Vauxhall Authorised Repairer. To ensure the full peda l travel can be utilized, especially in case of a fault in one of the b ra ke circuits, there m ust be no ma ts in the vicinity of the p edals – see p age 83.

Brakes When the engine is not running, the sup port of the brak e servo unit d isappears once the brake pedal has been depressed once or tw ic e. Bra king effect is not red uced, b ut b ra king requires significantly greater force. This is especially im portant to bear in mind when tow ing. Check the brake lights b efore starting out on a journey.

93

Shortly after starting ea ch journey the effectiveness of the brake system should be tested at low sp eed and without inconveniencing other traffic, especially if the brakes are wet, e.g. after the vehicle ha s b een washed. The brake fluid lev el should be checked regularly. If the brak e fluid level is too low and the hand brake is not a pplied, control indica tor R on the instrument panel illuminates – see page 20.

Picture no: 13483h.tif

Hand brak e Alway s apply hand brak e firmly. O n slopes app ly the hand brake as firm ly as possible. The mechanical hand brake acts on the brak es on the rear wheels. It eng ages automatically when app lied. To release the hand brake pull the lev er up slightly , press the ratchet knob, and fully lower the lever.

94

Brakes

9 Warning If the control indicator illuminates when the hand brake is not ap plied: Stop. Interrupt y our journey immediately. C onsult a w orkshop. We recommend your Vauxhall Authorised R epairer.

Pi cture no: 12949h.tif

Brak e system control i ndicat or R The c ontrol indicator illumina tes when the ignition is switched on if the hand brake is applied or if the brak e fluid level is too low. Brake fluid lev el - see pa ge 136.

Illuminated together with the control indicator for the Anti-lock Brake Sy stem u : the braking force on the rear wheels is not being regulated. The vehicle may swerve during braking. Have the cause of the fault remedied. We rec om mend that you consult your Vauxhall Authorised R epairer.

Anti-lock brake system (ABS u ) 3 ABS continually monitors the brake sy stem and p revents the wheels from lock ing regardless of the type of road surface or tyre grip. It starts to regulate the braking pressure as soon a s a wheel shows a tendency to lock. The vehicle rema ins steerable, even in the event of v ery heavy braking, for insta nce on bends or when swerving to a void an obstacle. Ev en in the c ase of full-on brak ing, the ABS mak es it possible to drive round an obstacle w ithout releasing the brak es. ABS control is mad e ap parent thoug h a pulse in the brake pedal and the noise of the regulation process.

Brakes

95

9 Warning

9 Warnin g

For optimum b ra king, keep the brak e pedal fully depressed throughout the braking p rocess, despite the fac t that the pedal is pulsating. Do not red uce the pressure on the pedal.

If there is a fault in ABS, the wheels may be subject to locking due to braking that is heavier tha n normal. The ad vantages of AB S are no longer opera tional. The vehicle can no longer b e steered and may swerve.

Do not let this special safety feature tempt y ou into taking risks when driving.

Y ou can continue driving, provided y ou drive with care and anticipation.

Traffic safety can only be achieved by adopting a responsib le driving style.

Pict ure no: 12950h.tif

Control i nd icator u for ABS When the ignition is switched on, the control indicator illuminates for a few second s w hile the system performs a selfcheck, which m ay be audible. The system is ready for operation when the control indica tor goes out. If the control indicator does not go out after a few sec onds, or if it illuminates while driving, there is a fault in the ABS . The brake sy stem rem ains operational without AB S reg ulation.

Hav e the cause of the fa ult remedied. We recommend that y ou consult y our Vauxhall Authorised Repa irer. The sy stem’s integrated self-diagnostics allows faults to be quickly remedied .

9 Warnin g If the ABS control indicator illuminates tog ether with the control indicator for the brake system R, the braking force on the rear wheels is not being regulated. The vehicle m ay sw erve d uring braking. Hav e the cause of the fault remedied . We recommend that you consult your Vauxhall Authorised Repairer.

96

Wheels, Tyres

Wheels, Tyres

Tyres See pag e 152 for suitable ty res and restrictions. Ty res fitted in the factory are adapted to the chassis and provid e optimum driving comfort and sa fety.

Changing tyre/wheel type Before switching to different tyres or wheels, seek advice on the technical possibilities. We recommend that you consult y our Va ux ha ll Authorised Repairer, who will be able to advise y ou of any necessary mod ifications. Tyre pressure... ..... .... ..... .... ..... .... .... ..... . 97 Tyre condition, wheel cond ition ... ..... . 98 Winter tyres 3 . ..... .... ..... .... ..... .... .... ..... . 100 Wheel covers 3 .... .... ..... .... ..... .... .... ..... . 100 Tyre chains 3 .. ..... .... ..... .... ..... .... .... ..... . 100

9 Warning Use of unsuitab le tyres or wheels m ay lead to accidents and render the vehicle unroa dworthy .

Fitti ng new tyr es Fit tyres in pa irs or in sets, which is even better. Ensure tha t tyres on one axle are z the same siz e z the same design z the same make z and have the same tread pattern. Fit directional tyres such that they roll in the direction of trav el. The rolling direction is indicated by a symbol (e.g. an arrow) on the sidewall. Tyres fitted opposing the rolling direction (e.g. when a wheel is changed ) should be refitted as soon as possible. This is the only way to benefit fully from the d esign properties of the tyres.

9 Warnin g We recom mend that you have your ty res chang ed b y y our Vauxhall Authorised Repairer, who will b e familiar w ith the requirem ents of the law a s regards disposal of tyres and can thus help to protect the environm ent and y our health.

Wheels, Tyres

97

Some brands of tyres have a beaded edge for alloy wheels to protect against dam age. If wheel covers a re used on steel wheels with bead ed-edge tyres, the follow ing requirem ents must be fulfilled: z Use of wheel trims and tyres that approved by Vauxhall for the vehicle in question and thereby fulfil all requirements for the wheel and tyre com bination. z If the wheel covers and tyres used are not Vauxhall-approved, the tyres m ust not have a bead ed edge.

9 Warning Use of unsuitable tyres or wheel covers could lead to sudden pressure loss and thereby accidents.

Pict ure no: 13484h.tif

Tyre pressure

Check tyre pressures, inc luding the spare wheel, at least every 14 days and prior to any long journey; the tyres should be checked when cold. Don’t forget to check the spare. For tyre pressures refer to page 152 and the adhesive label on the left-side front door frame. After changing tyre sizes, have the label replac ed. Do not reduce ty re pressure when the tyres are wa rm. O therwise the pressure may drop b elow the perm issible minimum when the tyres cool down. Sec urely retig hten valve caps after checking the tyre pressures.

Pict ure no: 9358T.tif

Incorrect inflation pressures will impair safety, vehicle handling, comfort and fuel econom y and w ill increase tyre wear. If the pressure is too low , this can result in consid erable tyre warm-up and interna l dam age, lead ing to tread separation and even to ty re blow-out at high speeds. Hidd en tyre dama ge is not elim inated by adjusting inflation pressure.

9 Warnin g Incorrect ty re pressure could lead to a flat tyre.

98

Wheels, Tyres Check tyres regularly for dama ge (foreign bodies, punctures, cuts, crack s, bulg es in sidewalls). Chec k wheels for damage. In the event of dam age or abnorm al wear, consult a workshop. We recommend your Vauxhall Authorised Repairer.

9 Warning Dama ge m ay lead to ty re blow-out.

Pict ure no: 15941s.t if

Tyre condition, wheel condition Drive over edges slowly and at a rig ht angle if p ossible. Driving ov er sha rp edges can lead to hidden ty re damage a nd wheel dam age which is only noticed later on. When pa rk ing, ensure that the tyres a re not pressed against the ed ge of the kerb .

Picture no: 6456U.tif

Tread d ep th C heck tread depth regularly.

If w ear in the front is greater than that in the rear, m ov e the rear wheels to the front ax le and vice versa. C orrect tyre pressure. For reasons of safety , tyres should be replaced when their tread depth has worn down to 2 to 3 mm (winter tyres: 4 mm).

Wheels, Tyres General i nformati on z The danger of aq uap laning is greater if the ty res are worn. z Tyres age, even if they a re used only very little or not at all. A spare wheel which has not b een used for six years should be used only in emergencies; drive slowly when using suc h ty res. z Never fit used tyres the prev ious history and use of w hich y ou do not know. z So as not to im pair brake cooling , use only wheel trims app rov ed for use on your vehicle.

Picture no: 6457U.tif

The legally permissible minimum tread depth (1.6 m m) has been reached when the tread has worn down as far as one of the w ear indicators (TWI 1 )). A number of wear indicators a re spaced at equal intervals around the ty re within the tread. Their position is indicated by markings on the ty re sidewall.

1)

TWI = T rea d Wea r Ind ica to r.

Tyre d esigna tions Meaning s: e.g. 155/65 R 14 75 S 155 = Tyre width in mm 65 = Aspect ratio (ty re height to tyre width in %) R = Belt ty pe: Radial 14 = Wheel d ia meter in inches 75 = Load ind ex Ex. 75 = 390 kg S = Speed cod e S peed code letters: Q S T H V W

Up Up Up Up Up Up

to to to to to to

100 112 118 130 150 168

mph mph mph mph mph mph

99

100

Wheels, Tyres

Winter tyres 3 Information on fitting new tyres – see page 96. See page 152 for restric tions. Winter tyres im prove safety at tem peratures below 7 °C and should therefore be fitted on all the wheels.

Wheel covers

3 If the wheel trims and ty res used are not Vauxhall-app rov ed, make sure that the tyres do not have a b eaded edge – see page 96.

The d esign of summ er tyres mea ns they have limited qualities for winter driving. If the maxim um perm issible speed for the winter ty res is less than that of the vehicle, a notice ind icating the ma ximum permissible speed for the tyres must be affixed within the driver’s field of v ision 1). If y ou use the spare wheel when it is fitted with a summer tyre, the v ehicle’ s driveability may be affected, espec ia lly on slip pery roa d surfaces. Ob ta in a rep la cement for the faulty ty re as soon a s possible, and hav e the wheel balanced and fitted to the v ehicle.

Pict ure no: 6459u.tif

Tyre chains

3 S ee page 152 for restrictions.

Tyre chains are permitted on the front wheels. They must be fitted to the ty res symm etrically in order to achiev e a concentric fit. Use fine mesh chains. See page 152. We recommend that you consult your Vauxhall Authorised Repairer.

1)

Va ries fro m country to country o n account of nationa l regula tions .

Wheels, Tyres Wheel trim on steel wheels could come into contact with parts of the chain and be dam aged. Rem ove the wheel trim – see page 114. Tyre chains m ay only be used at speed s up to 30 mph and, when travelling on road s that are free of snow, they may be used for brief periods only since they are subject to rapid w ear on a hard road and may snap.

Tem porary sp are wheel 3 Ty re c hains must not be used on the temporary spa re wheel. I f you need to use tyre c hains after suffering a flat front tyre, fit the tem pora ry spare on the rear axle and transfer one of the rear wheels to the front ax le. For notes on the temporary spare wheel – see p age 111. Wheel changing – see page 114. Correcting tyre pressure – see pages 97, 152.

101

102

Roof racks, caravan and trailer towing

Roof racks, caravan and trailer towing

9 Warning Disregard of these notes can lead to injuries whic h may be fatal. Vehicle passengers should be informed accordingly.

Roof racks 3 For reasons of safety and to av oid dam aging the roof, w e recommend tha t y ou use the Vaux hall roof ra ck system app rov ed for y our v ehicle. Consult y our Vauxhall Authorised Repairer. Fasten the roof rack following the instructions that accompany the system. Driving hints – see page 82.

Towing eq uipm ent 3 .... .... ..... .... .... ..... . Ca ra van/trailer loa ds ... .... ..... .... .... ..... . Coupling socket loa d.... .... ..... .... .... ..... . Rear axle load during towing ... .... ..... . Tyre pressure... ..... .... ..... .... ..... .... .... ..... . Driving characteristics, towing tips ... . Starting on inclines .. ..... .... ..... .... .... ..... .

103 103 104 104 104 104 105

Roof racks, caravan and trailer towin g 3 Use only towing equipment tha t has b een approved for y our vehicle. We recommend entrusting the retrofitting of tow ing equipm ent to y our Vauxhall Authorised Repairer, who will advise y ou on any possible towed load increases. Your Vauxhall Authorised Repairer ha s instructions on how to install the towing equipm ent and m ake any necessary changes to the vehicle that affect the cooling sy stem, heat shields or other equipm ent.

Caravan/trailer loads 1)

Mounting dimensions of towing eq uipm ent – see pa ge 157.

The permissible caravan/trailer loads for your vehicle are given in the vehicle docum ents. Unless otherwise stated, they are v alid for gradients up to ma x. 12 %.

Towing equipment

The permissible caravan/trailer loads are vehicle-dependent and eng ine-dependent maximum values which must not be exc eeded. The actual c aravan/trailer load is the difference between the actual g ross weight of the caravan/trailer and the actual coupling socket load w ith the caravan/trailer coupled. When the caravan/trailer load is being checked, therefore, only the carava n/trailer wheels – and not the jockey wheel – must be standing on the weighing app aratus.

The permissible caravan/trailer load should be fully utilised only by d riv ers who are adeq uately experienced in towing large or heavy caravans/trailers.

1)

Obs erve na tiona l reg ula tio ns.

103

The permitted carava n and trailer load app lies up to the specified incline and up to an altitud e of 1000 metres above sea level. S ince engine power decreases as altitud e increa ses b ecause of the air becoming thinner, therefore reducing climb ing ability, the permitted towing weight also decreases by 10 % for every 1000 metres of add itional altitude commenced. The towing weight d oes not have to be reduc ed when driving on roads with slight inclines (less than 8%, e. g. motorways). The actual caravan/trailer load p lus the actual g ross weight of the towing vehicle must not ex ceed the maximum permitted towing weight. For exa mple, if the permitted gross vehicle weight is utilised, the trailer/carav an load must only be used until the ma ximum permitted towing weight is reached . The maximum permitted towing weight is shown on the identification plate, see page 144.

104

Roof racks, caravan and trailer towing

Coupling so cket load

Driving characteristics, towing tips

The c oupling socket load is the load exerted by the trailer/caravan on the coupling ball. It can b e varied by changing the w eight distribution when loa ding the trailer/caravan.

In the ca se of trailers/caravans with brake, attach break away stopping cable to eye at the side on the coupling ba ll bar. Before attaching the trailer/carav an, lubricate the ball of the trailer/caravan towing device. However, do not lubricate the ball if a stabiliser, w hich a cts on the coupling ball, is b eing used to d amp snaking.

The ma ximum permissible coup ling socket load (35 kg) for the towing vehicle is stated on the type plate of the towing equipment and in the vehicle documents. Alway s aim for this. The coupling load should nev er be less than 25 k g. When mea suring the coup ling socket load, mak e sure that the drawbar of the loa ded trailer/caravan is at the sa me height as it will be when the trailer/caravan is coupled with the towing vehicle load ed. Particularly important for trailers/carav ans w ith tandem axle.

Rear axle load during to wing When the caravan/trailer is coupled and the towing v ehicle fully loaded (including all occupants), the p ermissible rea r axle load (see identifica tion plate, page 144, or vehic le documents) ma y be exceeded by 15 kg and the perm issible gross vehicle weight by 27 kg . I f the perm issible rear axle load is ex ceeded , a m aximum speed of 50 mph (80 km/h) applies. I f na tional reg ulations specify a lower m aximum speed for vehicles towing a caravan/tra iler, this must be observed.

Picture no: 9358t.tif

Tyre pressure

Increase the tyre pressure on the towing vehicle to the v alue specified for a full load – see page 152. Also check the p ressure of the spare wheel and carava n/trailer wheels.

C heck c aravan/trailer lighting before starting to drive. The fog tail lig hts on the vehicle a re deactivated when towing a carav an or trailer. Trailers with LED turn signals m ust have a provision enables light m onitoring for comm ercial bulbs. Turn signal control indicator – see page 19.

Roof racks, caravan and trailer towin g Handling is greatly influenced by the loading of the trailer/carav an. Loads should therefore be secured so that they cannot slip and be placed in the c entre of the trailer/carav an if possible, i.e. above the a xle. In the case of trailers/c aravans with low direc tional stability, a speed of 50 mph (80 k m/h) should not be exceed ed; the use of a stabilizer which functions acc ording to the friction principle is strongly recom mended. Do not drive faster tha n 50 mph (80 km/h) if possible, even in c ountries where higher speeds are p ermitted . Make sure that y ou hav e enough room when c ornering and avoid sudden manoeuv res. If the tra iler/ca ra van starts to sway , drive more slowly, do not attem pt to correct the steering and brake sharply if necessary. If it is nec essary to apply the brak es fully , depress the brake pedal as hard a s possible. Remem ber that the braking distance for vehic les towing caravans/trailers w ith a nd without brake is a lways grea ter than that for vehicles not towing a caravan/trailer.

105

When driving downhill, towing a cara van/ tra iler subjects the b rakes to a heavier load than normal. For this reason, select the sam e gea r as when driving uphill and drive at a similar speed. The cooling fan is electrically operated. Its cooling p ow er is therefore independent of the engine speed. Since a considerable amount of heat is genera ted at high engine speeds and less at slower speeds, do not shift d ow n when climbing hills whilst the v ehicle is still coping with the gradient in the higher g ear. Diesel engine: O n gradients of 10 % or more, do not drive fa ster tha n 20 mph (30 km/h) in 1st gear or 30 mph (50 k m/h) in 2nd g ear.

Picture no: 11804h.tif

Starting o n inclines

The most fav ourable eng ine speed when starting off on a n incline is between 2500 and 3000 rpm for petrol eng ines and between 2000 and 2500 rpm for diesel eng ines. Hold engine rpm constant, ease the clutch out grad ually , release b ra ke – and open throttle. If p ossible, the engine speed should not d rop during this procedure. Before starting off under ex treme conditions (high combination weight, mountainous terrain w ith steep inclines), switch off all unnecessary electrical loads (e.g. heated rear window, air conditioning system 3).

106

Self-help

Self-help

9 Warning Disregard of these notes can lead to injuries whic h may be fatal. Vehicle passengers should be informed accordingly.

Starting the engine with jum p leads 3 Towing the v ehicle... ..... .... ..... .... .... ..... . Towing service ..... .... ..... .... ..... .... .... ..... . Towing another vehicle.... ..... .... .... ..... . First-aid k it (c ushion) + 3 and warning tria ngle ¨ 3 .... ..... .... .... ..... . Vehicle tools .... ..... .... ..... .... ..... .... .... ..... . Spa re wheel. .... ..... .... ..... .... ..... .... .... ..... . Jac k . .... ..... .... .... ..... .... ..... .... ..... .... .... ..... . Changing wheels . .... ..... .... ..... .... .... ..... . Electrical system .. .... ..... .... ..... .... .... ..... . Fuses ... ..... .... .... ..... .... ..... .... ..... .... .... ..... . Bulb replacem ent .... ..... .... ..... .... .... ..... . Halogen headlight system .... .... .... ..... . Tail lights . .... .... ..... .... ..... .... ..... .... .... ..... . Additional brake light 3 .. ..... .... .... ..... . Numb er plate light .. ..... .... ..... .... .... ..... . Courtesy lig ht .. ..... .... ..... .... ..... .... .... ..... .

107 108 109 109 110 111 111 113 114 118 118 122 122 124 125 126 126

Starting Do not sta rt wit h quick charger This prevents d amage to electronic components. Do not sta rt by pushing or towing Because your vehicle is fitted with a cataly tic converter, it must not be started by pushing or towing – see page 88. The v ehicle can only be started using jum p leads – see follow ing page.

Self-help

107

z Use auxiliary battery with sam e v olta ge (12 volts). Its capacity (Ah) m ust not be considera bly less than that of the discharged ba ttery. Voltage and capacity information can be found on the batteries.

Starting the en gine with jump leads 3 A vehicle with a discharged battery can be started using jump lead s and the battery of another vehicle.

9 Warning

z Use jump leads with insulated terminals and a cross section of at least 16 mm2 .

This must be d one with extreme care. Any deviation from the following instructions could lead to personal injury or d amage resulting from ba ttery explosion, as well as to dam age to the electrical systems in both v ehicles.

z Do not disconnect the discharged battery from the vehicle. z Switch off all unnecessary electrical consumers. z Do not lean over the ba ttery during jump starting. z Never ex pose the b attery to nak ed flames or spark s.

z Do not allow the terminals of one lead to touch those of the other lead .

z A discharged battery can freeze at temperatures below 0° C or as high as 0° C . Defrost the ba ttery b efore connecting jump leads.

z Do not touch the vehicles while jump starting.

z Do not allow battery fluid to come into contact with eyes, skin, fa bric s or painted surfaces. The fluid contains sulp huric ac id which can cause injuries and d amage in the event of d irect contact. z Wear eye protec tion and protective clothing when handling a b attery.

z Apply hand b ra ke. Transmission in neutral.

108

Self-help z Do not connect leads to negative term inal of discharged battery! z The connection p oint should be as far away from the discharged battery as possible. z Route the lead s so that they cannot catch on rotating parts in the engine compa rtm ent. z Start the engine of the vehicle providing the jump start. z After 5 minutes, start the other engine. Start attempts should b e m ade at intervals of 1 m inute and should not la st longer than 15 seconds.

Connect the lea ds in the order shown in the illustration: 1. Connect one end of the first jump lead to the positiv e terminal 1 of the battery prov iding the jump start (identified by "+" sign on battery case or terminal). 2. Connect the other end of this lea d to the positive terminal 2 of the discharged battery (" +" sign). 3. Connect the first end of the other jump lead to the negativ e terminal 3 of the battery prov iding the start ("–" sign). 4. Connect the other end of the second jump lead 4 to ground on the other vehicle, e. g. engine block or screw connection in the engine suspension.

z After starting, allow both engines to idle for approx. 3 minutes with the leads connected. z In order to avoid excess v oltage in the electrical system, before remov ing a lead, switch on an electrical consum er (e. g. light, heated rear window) in the vehicle receiving the jump start. z Reverse above sequence ex actly when rem oving lead s.

Towing the vehicle The towing eye is located behind a flap. To open, release the fla p at the bottom and pull downward. To close, position the flap at the top and engage at the bottom. Attach a tow rop e 3 – or better still a tow rod 3 – to the towing ey e. The tow ing eye is only to be used for towing, not for rec ov ery.

Self-help Switch on ignition to release steering column lock and to permit operation of brake lights, horn a nd windscreen w ip ers. Manual transm ission in neutra l. Drive slowly . Do not drive jerkily . Ex cessive tractive forc e ca n damage the vehicle.

9 Warning Significa ntly greater force is required for braking: the brake servo unit is only op erational when the engine is running. Considerably g reater steering force is necessary since this unit is operative only when the engine is running.

109

To prev ent the entry of exhaust fumes from the towing vehic le, switch on the air recirculation sy stem and close the wind ow s. Consult a work shop. We recom mend y our Vauxhall Authorised Repairer, w ho w ill serve you best to get your vehicle ba ck on the road.

Towing service Entrust y our v ehicle only to the towing service of your choice and obta in a n estimate of towing costs before employing any towing service. In this way you avoid unnec essary costs and p ossible insura nce prob lems during claim proc essing.

Towing another vehicle Towing eye at rea r in centre, below the bumper. Attach tow rope 3 – or, better still, tow rod 3 – to the towing ey e, never to the rear ax le. Drive off slowly and avoid jerky mov ements. Imperm issible trac tiv e forces could da mage the vehicles.

110

Self-help Not es on load ing see page 48.

First-aid kit (cushion) + 3 an d warning triangle ¨ 3 Stow the first-aid kit (cushion) in the storag e net 3 on the rig ht side panel of the luggage compartment.

The warning triangle is stowed in a recess on the rear panel under the luggage compartment floor covering . To raise the floor c ov ering, first rem ov e the storage box 3 – see pa ge 45. Unclip the floor covering and fold it forwards – see next pa ge. To close the comp artment fold down the floor c ov ering, insert it in the rec esses at the rear and clip it into place – see nex t page. Refit storag e box 3. When loa ding the vehicle, always ma ke sure the first-aid kit is accessible.

Self-help

Vehicle tools The v ehicle tools have been specia lly developed for your vehicle and should only be used for such. The vehicle tools are stowed in the luggage compartment und er a floor cover. To raise the floor cover, first remove the storag e box 3, see page 45. Raise the floor cover.

The vehic le tools are stowed betw een the ja ck and the rear panel of the lugg age compartment. To close the comp artment fold down the floor c ov ering, insert it in the rec esses at the rear and clip it into place. Refit storage box 3.

111

Spare wheel The spare wheel is stowed in the lug gage compa rtm ent under a floor c ov er and is secured by a wing nut. To open the floor cover, first remove the storage box 3 (see pag e 45). Raise the floor c ov er. Release wing nut and rem ov e. C ha nge the wheel. Stow the replac ed wheel in the vehicle and secure it in place. Fold down the floor cover and insert it in the recesses at the rear. Refit the stora ge b ox 3.

112

Self-help

Genera l informa tion O n vehicles w ith a lloy wheels 3 the spare wheel may have a steel rim. If y ou use winter tyres 3, the spare wheel may still be fitted with a summer tyre. I f you use the spare wheel the vehicle’s ha nd ling may be altered. O btain a replacement for the faulty tyre a s soon as possible, and have the wheel b alanc ed a nd fitted to the vehic le.

The spare wheel may hav e a sm aller tyre and a smaller rim than the wheels m ounted on the vehicle 1 ): Using the spare wheel may alter vehicle handling. H ave the defectiv e tyre replac ed as soon as possible, balance the wheel and ha ve it mounted on the vehicle.

Not es on di rect ional tyres 3 Direc tional ty res only provide max imum performa nc e w hen they are mounted in the correc t direction of rotation. If the ty res or spare wheel must be m ounted opposing the specified direction of rota tion (e.g. after chang ing a flat tyre), observe the following : z Vehic le handling may cha ng e. Ha ve the defective ty re replaced as soon as possible, and have the wheel balanced and mounted on the vehicle. z Do not drive faster than 50 mph (80 km /h). z Be especially careful when driving in rain and snow. Further information on directional ty res see page 96.

1)

Coun try-sp ecific version : T he sp are wheel is on ly to be u sed a s a temp orary spa re w heel.

Self-help The jack is secured b y a brac ket in front of the rea r panel of the luggage compartment. Turn the threaded rod to relea se the jack and then remove it. To refit the ja ck, position it und erneath the bracket and secure it by turning the threaded rod. Replace the spare wheel, fold d ow n the floor cover, insert it in the recesses at the rear, see previous page. Refit storage box 3 .

Jack The jac k has been specially dev eloped for your vehicle and should only be used for suc h. The ja ck is only suita ble for use w hen changing wheels. The jac k is stowed in the lugg age compartment under a floor cover. To open the floor cover, first remove the storag e box 3 (see page 45). Raise the floor cover. Taking out the spare wheel – see pa ge 111.

113

114

Self-help

Changing wheels To ensure y our safety , ma ke the following preparations and observ e the following inform ation w hen changing wheels: z Park the vehicle on a level, firm and nonskid surface. z Switch on the haza rd warning lights, apply the hand brake, engage 1st gear or reverse. z Correctly set up the w arning triangle. Warning triangle – see page 110. z Ta ke the spare w heel from the luggage com partment. z Before raising the v ehicle, set the front wheels to the straight-ahead position. z Slacken the wheel bolts one half turn before raising the vehicle, but do not totally unscrew the bolts. z Nev er change more than one wheel at once.

z Block the wheel diagonally op posite the wheel to be changed by placing wedge blocks or equiv alent in front a nd behind the wheel. z Use the jack only to chang e wheels. z If the ground on which the vehicle is standing is soft, a solid board (max. 1 cm thick) should b e pla ced under the jack . Using a thicker b oard c ould dam age the jack and the v ehicle.

z No people or a nima ls m ay be in the vehicle when it is jack ed up. z Never cra wl und er a ja cked-up vehicle. z Do not start or run the engine while the vehicle is on the jack. z Fully tighten the wheel bolts after low ering the vehicle.

Self-help

1. Prise off the wheel cover 3 with the flat end of the crank from the v ehicle tools. Vehicle tools – see page 111.

Alloy w heels 3: Disengage the wheel bolt caps with a screw driver and remove from the wheel bolts. Protect the wheel b y inserting a soft cloth b etween the screwdriv er and a lloy wheel.

115

Alloy wheels with anti-theft lock 3: Release the hub cap using the key found in the vehicle tools or in the glove compa rtm ent and remove it.

116

Self-help

2. Slacken wheel bolts using a w heel b olt socket wrench, putting socket wrenc h on as far as it will go.

3. Locators at the front and rear on the vehicle underb od y – each b etween two mark ings – indicate the points w here the jack is to b e attac hed.

4. Before positioning the jack, set it to the necessary height by rotating the eye by ha nd . Position the jac k at the front or rear so that the jac k claw spans the vertical b ase betw een the markings and grips in the rec ess in the vertica l base. Make sure it is properly positioned. The jack base m ust be on the ground directly below the jacking point in a manner that prevents it from slipping.

Self-help

117

10. Align and refit w heel cov er 3 . Before refitting the wheel cov er clean the w heel a round the retaining clips. Valve symb ol 3 on ba ck of w heel cover must point tow ards valve on wheel. Alloy wheels 3: Fit the wheel bolt caps 3 onto the wheel bolts. Alloy wheels with anti-theft lock 3 Insert pin on back of hub cap into corresponding hole in wheel. Insert and tighten anti-theft lock 3 .

Attach the crank in the hole in the threaded rod and fit the ey e of the wheel bolt wrench on the cra nk .

5. Unscrew wheel bolts a nd put somewhere where the threads will not be soiled.

Raise vehic le by turning cra nk .

6. C hange the wheel. For further inform ation – see pages 96, 111, 114.

If this is not the case, carefully low er the vehicle immediately and rep osition the ja ck.

7. Sc rew in wheel bolts and tig hten slightly, inserting the wheel bolt wrench as far a s the stop. 8. Lower v ehicle. 9. Tighten wheel bolts crosswise, putting on wheel bolt wrench as far as possible.

11. Stow a way replaced wheel, tools and warning triangle in the luggage compartment. 12. Check the pressure of the new ly mounted ty re. Correct if necessa ry . 13. Have the tightening torque of the wheel bolts on the new wheel checked on the vehicle using a torque wrench as soon as possib le and , if necessary, corrected. Tightening torque – see page 152. 14. Replace the faulty tyre on the wheel that was rem oved.

118

Self-help

Electrical system

9 Warning Elec tronic ignition system s generate very high v oltag es. Do not touch the ignition system ; high voltage can be fatal.

Fuses Fuse box Depend ing on engine v ariant, the v ehicle ha s three fuse box es: one in the passenger compartment below the dashb oa rd on the driver’s side and two 3 on the left side of the engine compartment.

To open the fuse box in the passenger compa rtm ent, press the tab on the cov er and remove the c ov er. The assignment numbers of the fuses are shown on the insid e of the cover. Before rep la cing a fuse, turn off the respective switch a nd the ignition. It is a good idea to carry a complete set of fuses, availab le from any Va ux ha ll Authorised Repa irer.

Self-help

Store spa re fuses 3 in the place provided on the inside of the cover.

To help in replacing fuses, there is a spec ia l fuse-gripping tool in the fuse box (shown in yellow in illustra tion).

119

A defective fuse can b e recogniz ed by its melted wire. A new fuse should only be insta lled after the cause of the troub le has been rectified. O nly fuses of the sp ecified rating should b e insta lled. The rating is given on each fuse and c an also be identified by the fuse colour. Fuses colour Red Blue Yellow White Pink (Maxi-Fuse) Yellow (Maxi-Fuse) Black (Max i-Fuse)

Fuses rating 10 A 15 A 20 A 25 A 30 A 60 A 80 A

120

Self-help No. Circuit

Fuses and the m ost importan t circuits they protect Fuse box in pa ssenger compa rtment No. Ci rcuit 1 Fog tail lights 2 Brake light 3 Electronic immobiliser, infotainment sy stem, courtesy light

Rating 10 A 15 A 15 A

Rat ing

4 Heated rear window 5 Central lock ing sy stem

15 A 20 A

6 Hazard w arning lights 7 Air conditioning system

10 A 10 A

8 Ta il light 9 Courtesy light,

10 A 15 A

10 Central lock ing sy stem, instruments, exterior mirrors

15 A

11 Electric windows 12 Airba g system

30 A 15 A

13 Immobilizer, power steering (EPS), instruments, air conditioning system

15 A

No. C ircuit

Rating

14 C entral locking system, 10 A turn signal lig hts, reverse lig hts, hea dlight rang e ad justment 15 Instrum ents 16 Windscreen w ip ers, windscreen washer system 17 ABS

10 A 15 A

18 Eng ine electronic s 19 C igarette lighter, acc essory socket 20 C entral locking system, exterior mirrors, infotainm ent system, instruments, control ind icators, cigarette lighter, acc essory socket.

15 A 15 A

21 Heater fan, hea ted rear window, air conditioning sy stem

25 A

10 A

15 A

Self-help

Eng ine compar tment fuse box b elow wi nd sc reen To open, press lug s a t sides and lift cover. No. Ci rcuit 1 ABS

Rating 60 A

2 Cooling fan 3 Power steering (EPS)

30 A 30 A

4 Starter 5 Lighting, engine, infotainment sy stem

60 A 60 A

No. Circuit 6 Alternator: petrol engine 7 Dip ped beam (right), main beam (right) 8 Instruments, control indicators, dipped bea m (left), main beam (left)

Rat ing 80 A

No. C ircuit 9 Rad ia tor fan, fuel injection system : petrol engine

121

Rating 20 A 30 A

15 A 15 A

10 Fog lights 11 Horn

15 A 15 A

12 –

–

122

Self-help Bulb replacement Before replacing a bulb, switch ignition off and switc h relev ant switch off. Only hold new bulb at base! Do not touch the bulb glass with bare hands, otherwise fingerprints on the g lass evaporate. Residue b uilds up on the reflector eventually resulting in a dull reflector. Inadvertently stained bulbs ma y be cleaned w ith a clean non-fluffy cloth, using alcohol or w hite spirits.

Eng ine compar tment fuse box a bove bat tery To open, pull off the cover upwards. No. Circuit 1 –

Rat ing –

2 – 3 Preheating system (1)

– 80 A

4 5 –

–

The rep la cement bulb must be in accordance with the data on the base of the defective bulb. Do not exceed w attage given on bulb base. Hea dlight aiming We rec om mend that headlight aiming b e carried out by your Vauxhall Authorised Repairer, who w ill have sp ecial equip ment. When adjusting hea dlights, headlight ra ng e ad justment m ust be set to 0.

Halogen headlight system Dipp ed and m ain beam 1. Open bonnet and engage support. 2. Detach plug connector from bulb base. 3. Remov e headlight protective cover.

Self-help

4. Disenga ge spring wire clip from reta ining lugs by moving it sideways and swivel it downw ards. 5. Remove bulb from reflector housing. 6. When fitting a new b ulb, eng age the lugs in the recesses on the reflec tor w ithout touching the glass. 7. Engage sp ring w ire clip. Plac e hea dlight protective cover in position and close cov er. Plug connector onto bulb b ase.

123

Pa rking lights 1. O pen bonnet and engag e support.

3. Diseng age bulb hold er from reflector housing .

2. Rotate bulb holder to left and disengage.

4. Remov e bulb from holder. 5. Insert new b ulb, without touching the glass. 6. Insert bulb holder in reflector housing and enga ge b y turning cloc kwise.

124

Self-help

Front indic ator lig hts 1. Open bonnet and engage support.

3. Disengage bulb holder from reflector housing.

2. Rotate bulb holder to right and diseng age.

4. Push bulb into holder a little, rotate left and remove.

1. Remov e both screw s between bulb housing and tailgate seal using screwdriver from vehicle tool kit.

5. Insert new bulb, without touc hing the glass.

2. Pull b ulb housing to rear so that it disengages from the locking elements.

6. Insert bulb holder in reflector housing and engage by turning anti-clockwise.

Tail lights

Self-help Additional brake light

3 We recommend that you have bulbs changed by a Vauxhall Authorised Repairer.

3. Rotate the bulb hold er anti-clockwise and pull out of the bulb housing. Bulb sequence from top to bottom: Ta il light/brake light Turn signal light Fog tail light (right-hand sid e) Reverse light (left-hand side). 4. Push b ulb into bulb hold er a little, rotate left and remove. 5. Push new b ulb into b ulb holder a little, rotate right and eng age. Do not touch the bulb glass. 6. Insert bulb hold er in reflector housing and engage by turning c lock wise.

7. Insert bulb housing into m ount with fixing pin and secure with screw s.

125

126

Self-help

Number plate light 1. Insert screwdriver vertically into number plate light at right, rotate clockwise and remove sp ring. Raise light insert on right and lift out.

2. Depress protruding tongue a nd open light housing. 3. Push bulb into bulb housing a little, rotate left and remove. 4. Push new bulb into bulb housing a little, rotate rig ht a nd engage. Do not touch the bulb glass. 5. C lose numb er plate light, insert and eng age in p osition.

Courtesy light C lose doors or hold down c ontact switch before remov ing lights so that they are not live. 1. Push lens to rea r and pull down to remove, a s shown in the illustration.

Self-help Instrument ill um ination, Informat ion displa y ill uminati on 3 We rec om mend that you have bulbs cha ng ed b y a Vauxhall Authorised Repairer.

2. Press bulb slightly towards spring clip and remov e. 3. Insert new bulb, without touching the glass. 4. Mount lens and engage in position.

127

128

If you have a problem

If you have a problem

The majority of areas of concern can be quic kly resolved in this way. Should you wish to pursue the matter further, the Principal of the Vauxhall Authorised Repairer should be made aware of your concern. It is ad visab le in cases such as this to write to him to confirm your problem and the solutions that have been offered.

In our ex perience the m ost comm on ca use of all comp la ints is the result of misundersta nding or la ck of communication between the customer and the Vauxhall Authorised Rep airer. We sincerely hope you will nev er have cause to c om plain about your vehicle. However, if things do g o wrong, the b est course of action for you to take is to contact your Vauxhall Authorised Repairer’s Service Rec eption Staff and explain the d ifficulty y ou are having. We are confident they will do their utmost to resolve the problem to y our comp lete satisfaction. Sometimes, however, despite the b est of intentions of all c oncerned, misundersta ndings can occur. If your problem has not been resolv ed to your satisfaction, please mak e an app ointment to discuss the matter with the Manager of the d epartment concerned.

You can be assured the Authorised Repairer’s Principal w ill only be too anxious to fully inv estigate y our prob lems and correct any errors m ade. After all, they ha ve a large inv estment in their business and are proud of their reputation and professionalism and fully realises that satisfied customers are their k ey to success. In the unlikely ev ent that you are still not ha ppy with the answer your Vauxhall Authorised Repairer has given, or the action prop osed to correct the problem , you may conta ct the C ustomer Care Department 1) w here a team of Custom er Care Consultants will spare no effort to ensure your complete satisfa ction. Va uxhall Motors Lt d. Customer Ca re, Griffin House, Osborne Road, LUTO N, Beds., LU1 3YT Telep hone: 01582 427200 They will review all the facts inv olved. Then if it is felt som e further action can be taken, 1)

Calls ma y be mo nito red and recorded fo r tra in in g p urp oses.

the Vauxhall Authorised Repairer will b e adv ised accordingly. In any case, y our contact will b e ac knowledged confirm ing Vauxhall Motors’ position in the m atter. If y ou are not satisfied with the outcome, y ou ca n if you wish, seek advice from an independent third p arty suc h as: Autom obile Association (A. A. ) Fanum House, BASI NGSTO KE, Hants., R G21 2EA Royal Autom obile Cl ub (R.A.C .), R.A. C. M otoring S ervices Ltd., 89-91 Pall Mall, LON DON , SW1Y S 45 The Customer Relations Dep artment, Soc iet y of Mot or Manufact ur ers and Trad ers Ltd. (S .M.M. T.), Forbes House, H alkin Street, LON DON , SW1X 7DS C ustomer Complaints Service, Sc ottish Motor Tra de Associ ation, (S. M.T.A.), 3 Palmerston Place, EDINBURGH, EH 12 5AQ The National Conciliation Serv ice, Retai l Motor I ndust ry Federation, 9 North Street, RUGBY , C V21 2AB I f you hav e a problem w hilst ab road:The S ervice Depa rtm ents of Adam O pel AG and General M otors branches every where will provid e information and assistance:

If yo u have a problem O pel Austria Vertriebs GmbH Groß-Enzersdorfer S tr. 59 1220 Vi enna – Austria Tel. 00 43 1-2 88 77 444 or 00 43-1-2 88 77 0

ADAM OPEL AG Bahnhofsp la tz 1 65423 Rüsselsheim – Germ any Tel. 00 49-61 42-77 50 00 or 00 49-61 42-7 70

O pel Belgium N. V. Prins Boudewijnlaa n 30 2550 Konti ch – Belgium Tel. 00 32-34 50 63 11

General Motors Hellas S.A. 56 K ifisias Avenue & Delfon str. Am arousion 151 25 Athens – Greece Tel. 00 30-1-6 80 65 01

O pel C & S spol. s. r. o. Na Pank ráci 26 140 00 Pra gue 4 – Czech R epub lic Tel. 00 420-2-61 21-88 21 General Motors Da nm ark Jaegersborg Alle 4 2920 Charlot tenl und – Denmark Tel. 00 45-39 97 85 00 Vauxhall Motors Ltd. Customer C are Griffin H ouse, Osborne Road Luton, Bedfordshire, LU1 3YT – Eng land Tel. 00 44-15 82-42 72 00 General Motors Finland O y Pajuniity ntie 5 00320 Helsink i – Finland Tel. Helsinki 00 358-61 58 81 General Motors France 1 – 9, avenue du Marais Angle Q uai de Bezons 95101 Ar gent euil Cedex – Franc e Tel. 00 33-1-34 26 30 00

Opel Southeast Europe Ltd . Szabad sag utc a 117 2040 Buda örs – Hungary Tel. 00 36-23 446 100 General Motors India Sixth Floor, Tow er A Glob al Business Park Mehrauli – Gurgaon Road Gurgaon 122 022, Ha ryana – Indi a Tel. 00 91-124 280 3333 Opel Irela nd Ltd. Opel House, Unit 60, Heather Road Sandyford, Dubli n 18 – I rel and Tel. 00 353-1-216 10 00 General Motors Italia S rl Piaz zale dell’Industria 40 00144 Rome – I taly Tel. 00 39-6-5 46 51 Opel Nederland B.V. Lage Mosten 49 – 63 4822 N K Breda – Netherlands Tel. 00 31-76-5 44 88 00

129

General Motors Norge AS K jeller-Vest 6 2027 Kj el ler – Norw ay Tel. 00 47-23 50 01 04 General Motors Poland Sp. z o. o. Domaniewsk a 41 06- 672 Wa rsa w – Pola nd Tel. 00 48-22-606 17 00 General Motors Portugal Q uinta da Fonte Edific ío Fernão Magalhães, Piso 2 2780-190 Paço d’ Arcos – Portugal Tel. 00 351-21 440 75 00 General Motors España S. L. Paseo de la Castellana, 91 28046 Madrid – Sp ain Tel. 00 34-902 25 00 25 S aab O pel Sverig e AB Esboga ta n 8 164 74 Kista – Sw eden Tel. 00 46-8-632 85 00 General Motors Suisse S.A. S telzenstraße 4 8152 Glatt brugg – Swi tzerla nd Tel. 00 41-44 828 28 80 O pel Türkiy e Ltd. S ti. K emalp asa yolu üzeri 35861 Torb ali/Izmir – Turkey Tel. 00 90-2 32-8 53-14 53 In Al bania, Bosnia -Her zegovi na , Bulga ria, C roatia , Macedonia , Rom ania, S lovenia and Yugosla via please contact the Opel S ervice Depa rtm ent in Budaörs – Hungary Tel. 00 36-23 446 100

130

Maintenance, Inspection System

Maintenance, Inspection System

In order to guarantee econom ical and safe vehicle operation and to m ainta in the value of y our v ehicle, it is of vital importanc e that all maintenance work is carried out at the proper intervals as specified b y Vauxhall. The date for the nex t serv ice is determined by time or kilometre/mileage interva ls – whic hever is reached first. InSP app ears in the trip odom eter display after the ig nition is sw itc hed on when it is tim e for servic ing: Have service work carried out within one week or 300 miles (500 k m). We recommend that y ou consult your Vaux hall Authorised Repairer.

A note on safety .. .... ..... .... ..... .... .... ..... . Checking and topping up engine oil . . Engine oil . .... .... ..... .... ..... .... ..... .... .... ..... . Coolant .... .... .... ..... .... ..... .... ..... .... .... ..... . Coolant .... .... .... ..... .... ..... .... ..... .... .... ..... . Brake fluid ... .... ..... .... ..... .... ..... .... .... ..... . Wind screen wiper .... ..... .... ..... .... .... ..... . Wind screen wash system . ..... .... .... ..... . Battery ..... .... .... ..... .... ..... .... ..... .... .... ..... . Protecting electronic components .... . Vehicle decomm issioning. ..... .... .... ..... . Vehicle recommissioning.. ..... .... .... ..... .

131 131 132 134 134 136 137 137 138 139 139 139

The service interval display takes account of off-the-road p eriods during which the battery is d isconnected. Further inform ation on m aintenance and the inspection sy stem can be found in the service book let, w hich is in the glove compartment.

Picture no: 15218H.tif

Hav e m aintenance w ork – as well as repairs to the bodywork and power units – carried out by a professional. We recommend your Vaux hall Authorised Repairer, who is w ell acq uainted with Vauxhall vehic les and in possession of the spec ia l tools required and the respectiv e latest service instructions from Vauxhall. In order to avoid inva lid ation of any warranty claim, it is especially important to entrust work to a Vaux hall Authorised Repairer during the warranty period. For further inform ation, see the Service Booklet.

Mainten ance, Inspection System

131

Separ ate anti-cor rosion servi ce Follow the intervals specified in the Service Booklet. We recommend tha t you entrust this work to your Vaux hall Authorised Repairer.

Picture no: 6526u.tif

A note on safety

Alw ays switch ignition off w hen perform ing checks in the engine c om partment (e.g. checking the brake fluid lev el or the engine oil level) due to risk of injury from liv e c ables and rotating parts.

9 Warning The cooling fan is controlled by a thermoswitch and ca n therefore start unexp ectedly even if the ignition is switched off. Risk of injury. Electronic ignition systems generate very high voltages. Do not touch the ignition system; hig h voltage can be fatal.

Picture no: 16191h.tif

N ever carry out any repairs or adjustment and m aintenance work on the vehicle y ourself. This especially applies to the eng ine, chassis and safety parts. You may unwittingly infringe the p rov isions of the law and, by not performing the work properly , endanger y ourself and other road users.

Checking and topping u p engine oil To aid identification, the engine oil filler cap and the handle of the oil d ip stick are coloured y ellow.

132

Maintenance, Inspection System

Pi cture no: 16192h.tif

Engine oil

Information on engine oils is available in the S ervice Booklet. Eng ine oi l level, engine oil consump tion Ev ery engine consumes engine oil for tec hnical reasons. The engine oil consump tion cannot be assessed until a fairly long distance has been driv en, a nd may be a bove the specified value when the vehic le is first b eing driven (run-in period ). Frequent d riv ing at high revs increases engine oil consumption. In vehicles with engine oil lev el check 3, the engine oil level is checked automatically. It is particularly adv isable to check the engine oil level before emb arking on a long journey.

Pict ure no: 16193h.tif

Engine oil l ev el chec k, topping up engine oil The illustrations show chec king and top ping up of various petrol and diesel engines. The oil lev el m ust be check ed with the vehicle on a level surface and with the engine (which m ust be at operating temperature) switched off. Wait at least 5 minutes before c hecking the level to allow the normal engine oil acc um ulation in the engine to drain into the oil pan.

9 Warning Do not allow the engine oil level to drop below the m inimum level!

Picture no: 15155h.tif

To check the engine oil level, insert wiped oil dipstick into handle as fa r as it will go. Top engine oil up if the level has dropped into the range of the top-up m ark MI N. The engine oil level must not exceed the upper mark MAX on the dipstick. Excess eng ine oil must be drained off or extracted. If the engine oil level is above the M AX ma rk there is a risk of damage to the eng ine or the catalytic converter. The amount filled must be between the MI N and MA X marks – see pag e 155.

9 Warnin g It is the owner’s resp onsibility to ma intain the correct lev el of an appropriate quality oil in the engine.

Mainten ance, Inspection System

Pi cture no: 12068h.tif

Top up with the sam e b rand of engine oil that was used d uring the prev ious oil change, following the instructions in the Service Booklet. To close, position the ca p and sc rew it into place. Ca pacities – see p age 155.

Pict ure no: 12951h.tif

Engine oil change, engine oil filter change Change the oil at the disp la yed service intervals. We rec om mend that you use genuine Vauxhall engine oil filters.

133

Picture no: 15156h.tif

9 Warnin g

We recom mend that you entrust engine oil and filter changes to a Va ux ha ll Authorised Repairer, who will be fa miliar with the requirements of the law as regards disp osal of used oil and can thus help to protect the environment a nd your health.

134

Maintenance, Inspection System

Coolant During operation the sy stem is pressurized. The tempera ture may therefore rise briefly to over 100 °C . The g ly col-based c oolant provides excellent corrosion protection for the heating a nd cooling systems as well as anti-freez e protection d ow n to -28 °C . It rem ains in the cooling sy stem throughout the y ear and need not be changed. Certain anti-freezes can lea d to engine dam age. We therefore recommend the use of anti-freez es that have been approved by Vaux hall.

9 Warning Antifreeze is a d ang er to health; it must therefore be k ept in the original conta iner and out of the reach of children.

Picture no: 12952h.t if

Frost and c or rosi on p rotection Before the sta rt of the cold weather season, have the coolant checked for correct concentration using a calibrated hydrometer. We recom mend that you consult your Vauxhall Authorised Repa irer. The anti-freeze content must guarantee frost protection down to approx. -28 °C . An insufficient concentration will reduce frost and corrosion protection. Add anti-freez e if nec essary . If c oolant loss is topped up with wa ter, have anti-freeze c oncentration checked and a dd anti-freeze if necessary.

Mainten ance, Inspection System

135

After topping up with tap or distilled wa ter, have the anti-freeze concentration checked , and anti-freeze added if nec essary . Hav e the cause of the coolant loss remedied. We recommend tha t you consult y our Vauxhall Authorised Repairer. To close, position the cap and screw it into place. C ool ant temp era ture If the temp erature g auge is in the upp er warning zone, coolant temp erature is too high. C heck the coolant level imm ediately.

Pi cture no: 12519h.tif

Coola nt level Hardly any losses occur since the cooling system is sealed and it is thus rarely necessary to top up the c oolant. The c oolant in the exp ansion tank should be just abov e the marking KALT/CO LD or between LO W and FU LL in diesel engines with the c ooling system cold. It rises when the engine has warmed up and drops again as the engine cools. I f it falls b elow the m arking KALT/CO LD or b elow LOW during this, top up to just a bove the marking KALT/C OLD or between LOW and FULL.

Pict ure no: 16194h.tif

9 Warning

Allow engine to cool down before rem oving coola nt filler cap . Rem ov e filler cap carefully so that p ressure can escape slow ly, otherwise there is a risk of scalding. Top up anti-freeze. I f no anti-freeze is available, top up w ith c lean tap water. If tap water is unav ailable, distilled water can be used.

z Coolant level too low: Top up coolant. Pay attention to the instructions giv en under "Anti-freeze and corrosion protection" and " Coolant level". Have the cause of coolant loss remedied . We recommend that you consult your Vauxhall Authorised Repairer. z Coolant level O K: Have the c ause of inc reased coolant temperature remed ied. Contact a workshop. We rec om mend that you consult your Vauxhall Authorised Repairer.

136

Maintenance, Inspection System Use of certain b ra ke fluids could lead to damage or red uc ed b ra king effec t. Stay well informed! We recommend the use of Vauxhall-app rov ed high perform ance brake fluid when necessary. Extreme cleanliness is im porta nt as b rake fluid c ontamination could cause b rake sy stem malfunction. After correcting the brake fluid level, have the cause of brake fluid loss remedied . We recommend that you consult your Vauxhall Authorised Repairer.

Picture n o: 11252H.tif

Brake fluid

Brak e fluid level

9 Warning Bra ke fluid is poisonous and corrosive. Do not allow it to contac t ey es, skin, fabrics or painted surfa ces. Direc t conta ct may cause injuries a nd damage. The fluid level in the reserv oir must b e neither higher than the MAX m ark nor lower than the MIN mark.

Brak e fluid cha ng e Brake fluid is hygrosc op ic , i. e. it a bsorbs water. If the brakes become hot, such as when driving on long downhill stretches, va pour b ub bles can form in the water, which can hav e an a dverse effect on brak ing power (depending on the proportion of water). The fluid c hange interva ls specified in the S ervice Booklet m ust therefore be observed.

9 Warnin g We recommend that you have brak e fluid chang ed b y a Vauxhall Authorised Repairer, who will b e familiar w ith the requirem ents of the law a s regards disposal of brake fluid and ca n thus help to protect the environment a nd your health.

Mainten ance, Inspection System

137

Windscreen wiper Clear vision is essential for safe driving. The cleaning effect of the wind screen w iper should therefore be checked at reg ular intervals. We recomm end replacing the wiper blades at least once a year. If the windows are dirty, operate the windscreen wash before switching the wiper on in ord er to prevent w iper blad e wear. Do not switc h wind screen wiper on if windows are icy, since this may dam age the w iper edges or the wiper sy stem. If the wiper becomes frozen onto the glass, we recommend tha t it be released with the aid of Vauxhall De-icer S pray. Sm earing w ip er b la des ca n be clea ned w ith a soft cloth and Vaux hall Windscreen Wash Solvent. Wiper b la des whose lips have become hardened, cracked or c ov ered with silicone must be replaced. This may be necessary as a result of the effects of ice, tha wing salt or heat, or the incorrect use of cleaning agents. Switch off windscreen wiper in the car wash, see pages 9, 141. Wind screen wiper blade m aintenanc e - see page 142.

Picture no: 11253H.t if

Wi per blad e repla cement Lift wiper arm. Move relea se lev er and detach w ip er blad e.

Picture no: 13487h.tif

Win dscreen wash system

The fluid c ontainer for the windsc reen washer system and the rear window washer system is located on the rig ht-hand side of the engine compartment (viewed from the front of the vehicle).

138

Maintenance, Inspection System

Fill only with clean w ater to prevent the nozzles from clogging. To improve cleaning efficiency, we recommend that you add a little Vauxhall Wind screen Wash Solvent.

Parking the vehicle for more than 4 week s can discharge the battery. This ca n shorten the life of the battery. Therefore d isconnect the battery by d isconnecting the negative term ina l from the on-board power sup ply.

The w indscreen washer system will not freeze in winter:

Ensure that ig nition is switched off before connecting ba ttery. Failure to do so could result in the engine not being able to start or eng ine opera ting prob lems. Time and date must be set in the information disp lay after the battery is reconnected.

Freeze p rotection d ow n to – 5 °C – 10 °C – 20 °C – 30 °C

Mix ture strength – Vaux hall Windscreen Wash Solvent: Water 1:3 1:2 1:1 2:1

When closing the container, p ress the lid firmly over the beaded edge all the way round.

Battery

Picture no: 13488a.tif

The battery is maintenance-free.

9 Warning We recommend that you have battery changes ca rried out by a Vauxhall Authorised Repairer. The Vauxhall Authorised Repairer knows the laws concerning the disposal of used batteries and therefore protects the environment and y our health. Retrofitted electrical or electronic accessories can place an add itional load on the battery or even discharge the battery. We recommend that you consult a Vauxhall Authorised Repairer regarding technical possibilities, such as fitting a more powerful battery.

Mainten ance, Inspection System Protectin g electronic c omponents

Veh icle decommissioning

In order to prev ent faults in electronic components in the electrical system, never connect or disconnect ba ttery with engine running or ignition switched on. N ever start engine with battery disconnected, e.g . when starting using jump leads.

Observ e national regulations.

To avoid damaging the vehicle, do not mak e any modifications to the electrical system, e. g. connecting ad ditional consumers or tampering with elec tronic control units (chip tuning).

z Wash and preserv e the vehicle – see page 141.

9 Warning Elec tronic ignition system s generate very high v oltag es. Do not touch the ignition system ; high voltage can be fatal. Disconnect/connect vehicle ba ttery from / to electric al system. Disconnect the ba ttery from the vehicle electrical system before cha rg ing: First detach the negative and then the positive lea d. Do not rev erse the polarity of the battery, i.e. d o not c onfuse the terminals for the positive and negativ e leads. When connecting, start with the positiv e lead and then connect the nega tiv e lead.

If the vehicle is decommissioned for severa l months, the following work m ust be carried out in order to prev ent dam age. We recommend that you consult your Vauxhall Authorised Repairer.

z C heck protective coating in engine compa rtm ent and on underbody and rec tify where necessary. z C lean and p reserve rubber seals on bonnet and doors.

139

Vehicle storage z Park vehic le in dry and well-ventilated premises. Engage first gear or reverse. Pla ce w heel chock s or suchlike under wheels to p revent vehicle from rolling away. z Do not apply hand brake. z Disconnect b attery by disengag ing negative term inal from v ehicle electric al sy stem – see p age 138.

Vehicle recommissioning O bserve national regulations.

z C hange engine oil – see pa ge 133.

C arry out the following w ork before putting a vehicle back on the road. z Connect ba ttery – see page 138.

z C heck anti-freeze and corrosion protection – see page 134.

z Check tyre pressure and correc t if necessary – see page 152.

z C heck the coolant level, top up with a ntifreeze if necessary – see page 135.

z Fill up w indscreen washer system – see page 137.

z Drain the w indscreen washer system .

z Check engine oil level – see p age 132.

z Increase tyre pressure to value specified for full loa d – see pa ge 152.

z Check the coolant level; top up with antifreez e if necessa ry , see page 135. z Fit the num ber p la te if necessary .

140

Veh icle c are

Vehicle care

Obtain adv ice from a Vauxhall Authorised Repairer regarding cleaning materials tha t ha ve b een tested a nd recomm ended by Vauxhall. When caring for your vehicle, observe all na tional environm ental reg ulations, particula rly when wa shing it.

Washing .. .... .... ..... .... ..... .... ..... .... .... ..... . Waxing .... .... .... ..... .... ..... .... ..... .... .... ..... . Polishing .. .... .... ..... .... ..... .... ..... .... .... ..... . Wheels ..... .... .... ..... .... ..... .... ..... .... .... ..... . Paintwork dama ge.. ..... .... ..... .... .... ..... . Ex terior lights .. ..... .... ..... .... ..... .... .... ..... . Plastic and rubber parts .. ..... .... .... ..... . Wheels and tyres . .... ..... .... ..... .... .... ..... . Interior and upholstery . .... ..... .... .... ..... . Seat belts. .... .... ..... .... ..... .... ..... .... .... ..... . Wind ow s.. .... .... ..... .... ..... .... ..... .... .... ..... . Wind screen wiper blades. ..... .... .... ..... . Loc ks... ..... .... .... ..... .... ..... .... ..... .... .... ..... . Engine compartment.... .... ..... .... .... ..... . Underb od y .. .... ..... .... ..... .... ..... .... .... ..... .

141 141 141 141 141 142 142 142 142 142 142 142 143 143 143

Regular, thorough care helps to improve the appearance of your vehicle and maintain its v alue over the y ears. It is a lso prereq uisite for w arra nty claims for any paint or corrosion damag e. The following pages contain tips for vehicle care which, if used properly , will help combat the unav oida ble d amaging effects of the environment.

Vehicle care aids

3 Vehicle wash: z Wa sh brush, z Shampoo, z Sponge, z Insect Removal S ponge, z Chamois. Vehicle care: z Paintwork Clea ner, z Paintwork Polish, z Metallic Paintwork Wax , z Hard wa x, z Vauxhall Touch-Up Paint, z Vauxhall Touch-Up/Aerosol Paint, z Wheel Preserver, z Insect Remover, z Window Cleaner, z Vauxhall Cleaning S olv ent and AntiFreeze, z Silicone O il for Rubber Sea ls, z Cleaner.

Vehicle care Washin g The paintwork of your v ehicle is exposed to env ironmenta l influences, e. g. continuous changes in weather conditions, ind ustrial waste gases and dust or tha wing sa lts, so wash and wax your v ehicle regularly. When using a utoma tic car washes, select a programme which includes wax ing. Bird droppings, dead insects, resin, pollen and the like should be cleaned off immediately , as they contain aggressive constituents which can cause paint dam age. If using a car w ash, comply w ith the pertinent instructions of the ca r wash manufacturer. The windsc reen w ipers and rea r window wiper must be in their park position – see pa ge 12. Remove antenna 3 and roof rack 3. S tand on the door sill to rea ch them m ore easily. If y ou w ash y our v ehicle by hand, make sure that the insides of the wing s a re also thoroughly rinsed out.

Clea n edges and folds on op ened doors and flaps as well a s the area s they cover. Thoroughly rinse off and leather-off the vehicle. Rinse leather frequently . Use separate leathers for paint and w indow surfaces: remnants of wax on the wind ow s will impair vision. Observ e national regulations.

Waxing Wax your vehicle regularly, in pa rticular after it has been washed using shampoo and at the latest when wa ter no longer forms beads on the pa intwork, otherwise the paintwork will d ry out. Also wax edg es a nd folds on op ened doors and flaps as well a s the area s they cover.

Polishing Polishing is necessa ry only if the paint has become dull or if solid deposits have become attached to it. Pa intwork polish with silic one form s a protective film , ma king waxing unnec essary . Plastic body parts should not be treated with wax a nd polish. Use Metallic Paintw ork Wa x on vehic les with a metallic-effect paint finish.

141

Wheels Use a pH-neutral w heel c leaning agent to clean the wheels. Wheels a re painted and ca n be treated with the same ag ents as the body. For alloy wheels we recomm end use of Alloy Wheel Preserv er.

Paintwork damage Repair small areas of paint damage such as stone impac ts, scratches etc. imm ediately using an Va ux ha ll touch-up app lic ator or Vauxhall spray and touch-up paint before rust can form. If rust has already formed , have the cause remedied . We recommend that you consult your Vauxhall Authorised Repairer. Please also pay attention to surfaces and ed ges beneath the vehicle where which rust m ay have formed unnoticed for some time.

142

Veh icle c are

Exterio r lights

Wheels and tyres

Headlight and other protective lig ht bezels are made of plastic. If they require additional cleaning after the vehicle has been washed, clea n them with C ar Shamp oo. Do not use any ab ra sive or caustic agents, do not use an ice scraper, and do not clean them dry.

Do not use high-pressure jet clea ners.

Plastic and ru bber parts

In terior and uph olstery Clea n the vehicle interior, including the instrument panel fasc ia , using interior cleaner. The instrument panel should only be cleaned using a soft da mp cloth.

For additiona l cleaning of plastic and rubber parts use Interior Cleaner. Do not use any other agent, and in particular do not use solv ents or petrol.

Clea n fa bric upholstery with a va cuum cleaner and brush. To remove stains, use cleaner that is suitable for both fabrics a nd vinyl.

Do not use high-pressure jet cleaners.

Do not use cleaners such as acetone, carbon tetrachloride, paint thinner, paint remover, nail va rnish remov er, w ashing powder or bleach. Petrol is also unsuita ble. Open velc ro fa stenings in your clothing could damage the seat cushions. Close velcro fastenings.

Seat belts Alw ays keep seat belts clean and dry. Clea n only with luk ewarm water or C leaner.

Win dows When cleaning the hea ted rear window, ma ke sure that the heating element on the insid e of the window is not damaged. Use a soft lint-free cloth or chamois leather in conjunction with Window Cleaner a nd Insect R emover. Vauxhall Cleaning Solvent and Antifreeze is suitable for de-icing windows. For mec ha nical removal of ice, use a comm ercially available sharp-edged ice scraper. Press the scraper firmly against the glass so that no dirt can get under it and scratch the glass.

Win dscreen wiper blades Wax such as the wax used in car washes can c ause sm earing on the wind screen when the windscreen wipers are sw itc hed on. S mearing wiper blades c an be cleaned with a soft c loth and Vauxhall Clea ning S olv ent and Antifreeze. Rep la ce them if necessary – see page 137.

Vehicle care Locks The locks are lubrica ted with a high-grade lock cy lind er grease at the factory. Vauxhall lock cylinder grease prevents the locks from freezing up. O nly use de-icing agent in emergencies, as they hav e a degreasing effect and will im pair the func tion of the lock s. After using a de-icing agent, have the locks re-greased. We recom mend that y ou entrust this to your Vauxhall Authorised Repairer.

Engine co mpartment Areas of the engine compartment that are painted in the same colour as the vehic le must be looked after lik e any other p ainted surface. It is adv isable to wash the engine compartment before and after winter and preserve it with wax. Cover alternator and brake fluid reserv oir with plastic sheets before washing the eng ine. When washing the engine with a steam-jet cleaner, do not d irect the steam jet at components of the Anti-lock Brak e Sy stem 3 , the automatic air conditioning system 3 or the b elt drive and its components.

Protective wax that has been ap plied is also removed during the engine wash. For this reason, have the engine, brak e system components in the engine compartment, axle com ponents with steering, body parts and cavities thoroughly preserved with protective wax after the wash. We recommend that you consult your Vauxhall Authorised Repairer. An engine w ash ca n be p erformed in the spring in order to remov e dirt that has adhered to the engine comp artment, whic h may also have a high salt content. Check protectiv e w ax la yer and ma ke good if necessary. Do not use high-pressure jet clea ners.

Underbody Your vehicle has a factory-app lied PVC undercoating in the wheel arches (including the longitudinal mem bers) which prov ides permanent protec tion and needs no special maintenance. The surfaces of the vehicle underbody not covered by PVC are provided with a durable p rotective wax coating in critic al areas.

143

O n vehicles w hich are washed frequently in automatic c ar washes with underbody washing facility, the protective wax coating may be im paired by dirt-dissolving add itiv es, so check the underb od y after washing and have it wax ed if necessary. Before the sta rt of the cold weather season, check the PVC coating and protectiv e wax coating and, if necessary, ha ve them restored to perfect condition. C aution - c om mercially available bitumen/ rubber materials can damage the PVC coating. We recom mend that y ou ha ve underbody work ca rried out by an Vauxhall Authorised Repairer, who knows the prescribed materials and has experience in the use thereof. The underbody should be washed following the end of the cold weather season to remov e any dirt adhering to the underbody since this may also contain salt. C heck p rotective wax c oa ting and , if nec essary , have it restored to perfec t condition.

144

Tec hnic al D ata

Technical Data

Vehicle identification d ata.... .... .... ..... . Coolant, b ra ke fluid, oils .. ..... .... .... ..... . Engine data. .... ..... .... ..... .... ..... .... .... ..... . Performance.... ..... .... ..... .... ..... .... .... ..... . Fuel consump tion, CO 2 emission.. ..... . Weights, pay loa d and roof load .. ..... . Tyres ... ..... .... .... ..... .... ..... .... ..... .... .... ..... . Electrical system .. .... ..... .... ..... .... .... ..... . Ca pacities ... .... ..... .... ..... .... ..... .... .... ..... . Dimensions.. .... ..... .... ..... .... ..... .... .... ..... . Mounting dimensions of carav an/ tra iler towing equip ment .... .... .... ..... .

145 145 146 147 148 150 152 154 155 156 157

Pict ure no: 13489h.tif

Veh icle doc umen ts, identification plate The tec hnical d ata is determined in accordance with European C ommunity standards. We reserve the right to make modifications. S pecifications in the vehic le docum ents alwa ys have priority ov er those given in this manual. The identification plate is affix ed to the front right door frame.

Picture no: 13329j.tif

Information on identification plate: 1 2 3 4 5 6 7 8

Manufac turer Type approval number Vehic le identification number Permissible gross v ehicle weight Permissible gross train weight Maximum permissib le front axle load Maximum permissib le rear axle load Vehic le-specific or country-specific data

Technical Data In other design v ariants, the identification plate m ay also be affixed to the dashboard. Engine code and engine number: stamp ed on left-ha nd side of engine on crankcase.

145

Coolant, brake flu id, oils When topping up – coola nt, – brake fluid, – tra nsmission fluid we rec om mend that you consult your Vauxhall Authorised Repairer, who can adv ise you on the correct products to use. C aution: Use of unsuitable fluids can cause serious damage to the vehicle. Engine oils Information on engine oils is availab le in the Serv ice Booklet.

Pi cture no: 14072h.tif

Vehicle identification data The v ehicle identification numb er is stamped on the identification plate and in the engine com partment.

146

Tec hnic al D ata

Engine data Sales designation Eng ine code Numb er of cylinders Piston displacement

(cm 3)

1.0 TWINPOR T Z 10 XEP

1.2 TWINPORT Z 12 XEP

3

4

998

1229

Max . engine outp ut (k W) at rpm

44 5600

59 5600

Torque (Nm ) at rpm

88 3800

110 4000

Petrol

Petrol

95 (S )2 ) 98 (SP) 2) 91 (N) 2)3 ) –

95 (S) 2 ) 98 (SP) 2) 91 (N) 2)3 ) –

Max . permissible engine speed, continuous (rpm) ap prox .

6250

6200

O il consumption (l/1000 km)

0.6

0.6

Fuel type O ctane requirement unleaded or unleaded or unleaded

1) 2) 3)

(RO N) 1 )

Stan da rd h ig h-qu ality fuels, e.g. unlead ed DIN EN 228, Diesel D IN EN 590;N = No rm al (R eg ular), S = Sup er (P remium ), SP = Sup er Plus (P rem ium Plus), va lu e prin ted in bold : recomm ended fu el. Kn ock contro l s ys tem a utoma tically a d jus ts ig nition tim ing a ccording to typ e o f fuel used (octa ne nu mber). Slight reduction in engine p ower an d torq ue if 91 RON is us ed.

Technical Data Performance (approx. km/h) Eng ine 1 )

Z 10 XEP

Z 12 XEP

Max imum speed (mph) 2 )

90

100

1) Sa les desig nation – see pa ge 14 6. 2) The ma xim um s peed is a ch ieva ble with a m aximum of h alf p ayloa d. Optiona l eq uipm ent m ay reduce th e specified m aximum speed of the vehicle.

147

148

Tec hnic al D ata

Fuel consumption, CO 2 emission

Directive 80/1268/EEC (last c hanged by 1999/100/EC) has ap plied for the measurement of fuel consumption since 1996.

The direc tiv e is oriented to actual driving practices: urban d riv ing is ra ted at approx. 1/ and off-road driving with ap prox . 2 / 3 3 (urban a nd ex tra-urban c onsumption). Cold starts and acceleration phases are also tak en into consideration. The specification of CO 2 emission is also a constituent of the directive.

The figures given m ust not be taken as a guarantee for the actual fuel consumption of a p artic ular vehicle. All values are b ased on the EU base model with standard equipment. The calculation of fuel consumption as spec ified by directive 1999/100/EC takes acc ount of the v ehicle’ s kerb weight, ascertained in accordance with the said regula tion. Optional ex tras may result in slightly higher fuel consumption and CO 2 emission lev els than those quoted. S aving fuel, p rotecting the environm ent see page 84.

Technical Data Fuel consumption

(l/100 km approx.),

CO 2 emission

(g/km approx.)

Eng ine 1 )

Z 10 XEP

Z 12 XEP

Urban Ex tra-urb an Com bined CO 2

7, 0 5, 1 5, 8 139

7,6 5,1 6,0 144

1)

Sa les desig nation – see pa ge 14 6.

149

150

Tec hnic al D ata

Weights, payload and roof load Payload is the difference between the permissible gross vehic le weight (see identification plate) and the EC k erb weight. To calculate the kerb weight, enter the data for y our vehicle below: z Kerb weight from Ta ble 1, page 151

+ .... .... .... .. kg

z Weight of heavy accessories from Table 2, page 151 + .... .... .... .. kg The total

= .... .... .... .. kg

is the EC k erb w eight. O ptional equipment and accessories increase the kerb weight, which m eans that the p ayload will also change slig htly. Note the weights given in the vehicle documents and the identification plate.

The combined total of front a nd rear ax le loa ds must not exceed the perm issible gross vehicle weight. For exa mple, if the front ax le is bearing its m aximum permissib le load, the rear axle can only bear a load that is eq ua l to the gross vehicle weig ht m inus the front axle load. When a trailer/caravan has been coupled and the towing v ehicle is fully lad en (including occupants), the p ermissible rear axle load (see identification plate for specification) m ay be exceeded by 15 k g and the permissible gross v ehicle weight may be exceeded by 27 kg. I f the permissib le rear axle load is exceeded, a maximum speed of 50 m ph applies. If na tional regulations specify a lower maximum speed when towing, this must be ob served. See the identification plate or v ehicle docum ents for permissib le ax le loads.

Roof loa d The permissible roof loa d is 35 kg. The roof load consists of the weight of the roof rac k plus the load carried. The height of the loa d – measured from the roof rail – m ust not exceed 50 cm. Driving hints – see page 82.

Technical Data Weights (kg) : Table 1, Kerb weight 1)

151

Weights (kg) : Table 2, Heavy accessories

Model

Engine 2)

Agil a Expression

Z 10 XEP

1040

S un roof

15

Z 12 XEP

1055

Roof rail

12

Electronic power steering (EPS )

5

Agi la

Agil a wi th air con.

Z 10 XEP

1052

Z 12 XEP

1067

Agil a Desig n

Z 10 XEP

1105

Z 12 XEP

1120

Z 10 XEP

1117

Z 12 XEP

1132

Agil a Desig n wi th air con.

1) According to EC Directive 70/1 56/EC, in clud in g as sumed weigh ts for driver (68 kg), lu gg ag e (7

kg ) a nd a ll fluid s (ta nk 90% full).

2) Sa les desig nation – see pa ge 14 6.

152

Tec hnic al D ata

Tyres Restricti ons Not a ll tyres ava ila ble on the market currently meet the structural requirem ents. We recommend that you consult a Vauxhall Authorised Repairer concerning suitab le tyre mak es. These ty res have und ergone special tests to establish their reliab ility , safety and specific suitability for Vaux hall vehicles. Despite continuous ma rk et monitoring, we are unab le to assess these attributes for other tyres, ev en if they hav e been g ra nted approva l by the relevant authorities or in som e other form. Further information – see pa ge 96.

Winter tyres

3 If you use winter tyres, the spa re wheel may still be fitted with a summer tyre. I f y ou use the spare w heel the vehicle’s handling may be a ltered. O btain a rep la cement for the fa ulty tyre as soon as possible, and hav e the wheel balanced and fitted to the vehicle. Further inform ation – see page 100.

Tyre ch ains 3

Tyre pressure in bar/psi 2) The specified ty re pressures are valid for cold tyres. Increased tyre pressure resulting from extensive driving must not be reduc ed. The specified pressures apply to both summer and winter ty res. Alway s inflate the spare wheel to the tyre pressure for full load - see table on following page. Further information – see pages 96 to 100.

Ty re c hains may be used on the front wheels only. Only Vauxhall ty re chains, catalogue no. 47 05 448, may be used. They should be fitted to the front wheels only. Further inform ation – see page 100.

Wheels Wheel bolt tightening torque: 110 N m. On vehicles with alloy w heels 3 the spare wheel may ha ve a steel rim . The spare wheel may hav e a sm aller tyre and a smaller rim1) : using the sp are wheel may cause different d riv ing behav iour. Replace defective ty re as soon as possib le, balance wheel and have it fitted to the vehicle.

1)

Coun try-sp ecific version : T he sp are wheel is on ly to be u sed a s a temp orary spa re w heel.

2)

1 ba r corresp on ds to 100 kPa /14.5 p si.

Technical Data (ctd.)

Tyre pressure in bar/psi 1)

1)

1 ba r corresp ond s to 100 kPa /14.5 p si.

Ty re p ressure for load of up to 3 persons

Tyre pressure for full load

Engine2 )

Tyres

Front

Rear

Front

Rear

Z 10 XEP, Z 12 XEP

155/65 R 14, 165/60 R 14

2.3/33

2.3/33

2. 4/35

3.0/44

2)

Sales d esigna tion – s ee p a ge 146.

153

154

Tec hnic al D ata

Electrical system Battery

Voltage

12 Volt

Amp hours

36 Ah, 44 Ah, 55 Ah 3, 60 Ah 3

Battery for radio rem ote control of central lock ing sy stem

CR 16 16

Technical Data Capacities (a pprox. litre) Engine 1)

Z 10 XEP

Z 12 XEP

Fuel tank (nom inal content)

41

41

Engine oil w ith filter chang e between MIN and MAX on dipstick

3. 0

3. 5

1. 0

1. 0

Windscreen washer reserv oir

2. 2

2. 2

1)

Sales d esigna tion – s ee p a ge 146.

155

156

Tec hnic al D ata

Dimensions (mm) Agi la O verall length

3540

O verall w id th

1625

Width with two ex terior mirrors

1940

O verall height

1660

Height with roof rail

1695

Lug gage compartment length at floor

580

Lug gage compartment width maximum between wheel housing

1364 1115

Height of lugg age compartment opening

935

Wheelb ase

2360

Turning c ircle diam eter, wall to

1) 2) 3)

To rear seat ba ckrest. With fo ld ed rear sea t b ackrest. In metres.

wall3 )

1 )/1065 2 )

10. 60

Technical Data Mounting dimensions of caravan/trailer towing equipment All dimensions relate to trailer towing equipm ent app rov ed b y Vauxhall. Dimension

mm

A

380

B

245

C

100

D

100

E

10

F

538

G

50

9 Warning Only use towing eq uipm ent approved for your vehicle. We recommend entrusting retrofitting of towing equipment to y our Vauxhall Authorised Rep airer.

157

158

Index A ABS (Anti-lock Brake S ystem) .. .... ..... .... .. 94 Accessories . .... ..... .... ..... .... ..... .... .62, 65, 110 Accessory socket .... ..... .... ..... .... .... ..... .... .. 49 Air conditioning system ... ..... .... .... ..... .... .. 78 Air intake .... .... ..... .... ..... .... ..... .... .... ..... .... .. 80 Air outlet . .... .... ..... .... ..... .... ..... .... .... ..... .... ..80 Air recirculation system ... ..... .... .... ..... .... .. 74 Air vents . .... .... ..... .... ..... .... ..... .... .... ..... .... ..73 Airbags ... .... .... ..... .... ..... .... ..... .... .... ..... .... .. 57 Alternator ... .... ..... .... ..... .... ..... .... .... ..... .... .. 20 Antenna .. .... .... ..... .... ..... .... ..... .... .... ..... .... .. 26 Anti-corrosion service .. .... ..... .... .... ..... .... 131 Anti-freeze .. .... ..... .... ..... .... ..... .... .... .134, 138 Anti-freeze protec tion . .... ..... .... .... .134, 138 Anti-knock quality of fuel ..... .... .... ..... .... .. 86 Anti-theft loc king sy stem ..... .... .... ..... .... .. 33 Anti-theft protection ... .... ..... .... .... ..... .... .. 16 Aquaplaning .. ..... .... ..... .... ..... .... .... ..... .... .. 99 Ashtray ... .... .... ..... .... ..... .... ..... .... .... ..... .... .. 49

B Battery .... .... .... ..... .... ..... .... ..... ... 83, 138, 154 Before sta rting off .. ..... .... ..... .... .... ..... .... .. 14 Belt tensioners ..... .... ..... .... ..... .... .... ..... .... .. 51 Bonnet .... .... .... ..... .... ..... .... ..... .... .... ..... .... .. 37 Boot, see Lug gage compartment .... .... .. 41 Brake light .. .... ..... .... ..... .... ..... .... .... ..... .... 124 Brake system .. ..... .... ..... .... ..... .... .... ..... .... .. 92

Brakes .... .... ..... .... ..... .... ..... .... .... ..... .... ..... .. 92 ABS .... .... ..... .... ..... .... ..... .... .... ..... .... ..... .. 94 Brake fluid .. .... ..... .... ..... .... .... ..... .... ..... 136 Brake lights .... ..... .... ..... .... .... ..... .... ..... 125 Brake servo unit .. .... ..... .... .... ..... .... ..... .. 82 Foot brake .. .... ..... .... ..... .... .... ..... .... ..... .. 92 Hand brake .... ..... .... ..... .... .... ..... .... ..... .. 93 Bulb replacement ... .... ..... .... .... ..... .... ..... 122 Bulbs, . .... .... ..... .... ..... .... ..... .... .... ..... ... 65, 122

C Capacities . ..... .... ..... .... ..... .... .... ..... .... ..... 155 Car Pass .... ..... .... ..... .... ..... .... .... ..... .... ..... .... 2 Care ... .... .... ..... .... ..... .... ..... .... .... ..... .... ..... 140 Catalytic conv erter . .... ..... .... .... ..88, 91, 106 Central lock ing sy stem .... .... .... ..... .... . 31, 33 Changing the remote control battery .. .... .... ..... ... 32, 154 Changing tyre/wheel typ e .. .... ..... .... ..... .. 96 Changing wheels .... .... ..... .... .... ..... .... ..... 114 Chassis num ber, see vehicle identification num ber . ..... 145 Child restraint sy stems .... .... .... ..... .... ..... .. 62 Child safety lock s .... .... ..... .... .... ..... .... ..... .. 37 Child safety seats ... .... ..... .... .... ..... .... ..... .. 62 Cigarette lighter ..... .... ..... .... .... ..... .... ..... .. 49 Climate control .. ..... .... ..... .... .... ..... .... ..... .. 72 Clock .. .... .... ..... .... ..... .... ..... .... .... ..... .... ..... .. 24 Clutch operation ..... .... ..... .... .... ..... .... ..... .. 83 CO 2 emissions ... ..... .... ..... .... .... ..... .... ..... 148 Code num bers ... ..... .... ..... .... .... ..... .... ..... .... 2 Coding, octane num bers .... .... ..... .... ..... 146 Cold start .. ..... .... ..... .... ..... .... .... ..... .... ..... .. 84

C ontrol indicator ABS (Anti-lock Brake Sy stem) . ..... .... ... 95 Airb ag ... .... ..... .... .... ..... .... ..... .... ..... .... ... 60 Engine elec tronics .. ..... .... ..... .... ..... .... ... 90 Exhaust .. .... ..... .... .... ..... .... ..... .... ..... .... ... 89 Immobiliser ..... .... .... ..... .... ..... .... ..... .... ... 29 C ontrol indicators .. .... ..... .... ..... .... ..... ... 8, 18 Belt tensioners ... .... ..... .... ..... .... ..... .... ... 52 EPS (Electric Power Steering) .. ..... .... ... 18 C oolant ..... .... ..... .... .... ..... .... ..... .... .. 134, 135 C oolant level . ..... .... .... ..... .... ..... .... ..... .... . 135 C oolant tempera ture display . .... ..... .... ... 23 C oolant therm ometer .... .... ..... .... ..... .... ... 23 C ooling . ..... .... ..... .... .... ..... .... ..... .... ..... .... ... 78 C orrecting time .. .... .... ..... .... ..... .... ..... .... ... 24 C oupling socket load ..... .... ..... .... ..... .... . 104 C ourtesy light ..... .... .... ..... .... ..... .... ..... .... ... 68 C ourtesy lights Bulb replacement .. ..... .... ..... .... ..... .... . 126

D Dashboard, see Instrum ent panel .. .... .... ..6 Data . .... ..... .... ..... .... .... ..... .... ..... .. 28, 31, 144 Date display . ..... .... .... ..... .... ..... .... ..... .... ... 24 Day tim e running lights .. .... ..... .... ..... .... ... 66 Decommissioning .. .... ..... .... ..... .... ..... .... . 139 Demisting a nd Defrosting With the air conditioning system .... ... 79 Demisting a nd defrosting Windows .... ..... .... .... ..... .... ..... .... ..... .... ... 77 Dimensions .... ..... .... .... ..... .... ..... .... ..... .... . 156 Dipped beam ..... .... .... ..... .... ..... .... ..... .... ... 66 Bulb replacement .. ..... .... ..... .... ..... .... . 122 Display . ..... .... ..... .... .... ..... .... ..... .... ..... .... ... 24

159 Door locks ... .... ..... .... ..... .... ..... .2, 33, 37, 143 Driving abroad .... .... ..... .... . 68, 86, 128, 129 Driving hints ... ..... .... ..... .... ..... .... .... ..... .... .. 82

E Ec onomical driving . ..... .... ..... .... .... ..... 83, 84 Electric power steering .... ..... .... .... ..... 18, 82 Electrical system . .... ..... .... ..... 118, 139, 154 Electronic components .... ..... .... .... ..... .... 139 Electronic immobiliser .. .... ..... .... .... ..... .... .. 29 Engine code ... ..... .... ..... .... ..... .... .... ..... .... 146 Engine control indicator .. ..... .... .... ..... .... .. 90 Engine oil .... .... ..... .... ..... .... ..... .... .... ..... .... 132 Engine oil change ... ..... .... ..... .... .... ..... .... 133 Engine oil consumption ... ..... .... .... .132, 146 Engine oil filter .... .... ..... .... ..... .... .... ..... .... 133 Engine oil level .... .... ..... .... ..... .... .... ... 18, 132 Engine oil pressure .. ..... .... ..... .... .... ..... .... .. 21 Engine sp eed .. ..... .... ..... .... ..... .... .... ..... 82, 83 Engine wash ... ..... .... ..... .... ..... .... .... ..... .... 143 Env ironmenta l protection .... .... .... .133, 140 EPS . .... ..... .... .... ..... .... ..... .... ..... .... .... ..... .... ..18 Ex haust control indicator ..... .... .... ..... .... .. 89 Ex haust ga ses ..... .... ..... .... ..... .... .... ..... .... .. 90 Ex haust system ... .... ..... .... ..... .... .... ..... .... .. 90 Ex terior mirrors .... .... ..... .... ..... .... .... ..... .. 5, 65

F

G

Fan ..... .... .... ..... .... ..... .... ..... .... .... 72, 131, 132 Filling station Bulb replacem ent ... ..... .... .... ..... .... ..... 122 C apacities .. .... ..... .... ..... .... .... ..... .... ..... 155 Engine oil lev el .... .... ..... .... .... ..... .... ..... 132 Fuel .... .... ..... .... ..... .... ..... .... .... ..... ... 86, 146 Ignition key . .... ..... .... ..... .... .... ..... .... ..... .... 2 O pening the bonnet .... .... .... ..... .... ..... .. 37 Tyre pressure .. ..... .... ..... .... .... ..... .... ..... 152 Vehicle data ... ..... .... ..... .... .... ..... .... ..... 144 Windscreen wa sh system (filling) ..... 137 First-a id kit (cushion) .. ..... .... .... ..... ... 65, 110 Flat ty re . .... ..... .... ..... .... ..... .... .... ..... .... ..... 114 Fluid container Windscreen wa sh system .... ..... .... ..... 137 Fog lights .. ..... .... ..... .... ..... .... .... ..... .... ..... .. 67 Fog tail lig ht Bulb replacem ent ... ..... .... .... ..... .... ..... 124 Fog tail lig hts . .... ..... .... ..... .... .... ..... .... ..... .. 67 Foot brake . ..... .... ..... .... ..... .... .... ..... .... ..... .. 92 Front passenger a irba g .. .... .... ..... .... ..... .. 57 Fuel .... .... .... ..... .... ..... .... ..... .... .... ..... ... 86, 146 Fuel consumption ... .... ..... .... 83, 84, 86, 148 Fuel filter ... ..... .... ..... .... ..... .... .... ..... .... ..... 134 Fuel level ... ..... .... ..... .... ..... .... .... ..... .... ..... .. 23 Fuses .. .... .... ..... .... ..... .... .. 118, 120, 121, 122

Gears .... ..... .... ..... .... .... ..... .... ..... .... ..... .... ... 14 Generator, see Alternator .. ..... .... ..... .... ... 20 Genuine Vaux hall Parts and Accessories .. .... ..... .... ..... . 17, 65 Glove compartment .. ..... .... ..... .... ..... .... ... 47 Gross v ehicle weight . ..... .... ..... .... ..... .... . 150

H Halogen headlight system ..... .... ..... .... . 122 Hand brake ... ..... .... .... ..... .... ..... .... 15, 16, 93 Haz ard warning lights ... .... ..... .... ..... .... ... 11 Head restraints .. .... .... ..... .... ..... .... ..... .... ... 39 Headlight flash .. .... .... ..... .... ..... .... ..... .... ... 10 Headlight range adjustment .. .... ..... . 66, 67 Headlight switch ... .... ..... .... ..... .... ..... . 10, 66 Headlights .... ..... .... .... ..... .... ..... .... ..... .... ... 10 Daytime running lights ... ..... .... ..... .... ... 66 Driv ing abroad .. .... ..... .... ..... .... ..... .... ... 68 Fog lights .. ..... .... .... ..... .... ..... .... ..... .... ... 67 Reversing lig hts .. .... ..... .... ..... .... ..... .... ... 67 Wa rning device .. .... ..... .... ..... .... ..... .... ... 15 Headlights Changing bulbs . .... ..... .... ..... .... ..... .... . 122 Heated rear w indow . ..... .... ..... .... ..... . 13, 74 Heating ..... .... ..... .... .... ..... .... ..... .... 72, 76, 77 with the air conditioning sy stem . .... ... 79 Heating the foot well ..... .... ..... .... ..... .... ... 77 Height adjustm ent Seat belts .. ..... .... .... ..... .... ..... .... ..... .... ... 54 High-pressure cleaners .. .... ..... .... ..... .... . 143 Horn .. .... ..... .... ..... .... .... ..... .... ..... .... ..... .... ... 11

160 I Identification plate . ..... .... ..... .... .... ..... .... 144 Ignition sy stem .... .... ..... .... ..... 131, 138, 139 Imm ob iliser . .... ..... .... ..... .... ..... .... .... ..... .... .. 29 Information display ..... .... ..... .... .... ..... .... .. 24 Infotainm ent system .... .... ..... .... .... ..... .... .. 24 Inspection system ... ..... .... ..... .... .... ..... .... 130 Instrument illum ination Bulb replacement ..... .... ..... .... .... ..... .... 127 Instrument panel .... ..... .... ..... .... .... ..... .... .... 6 Instruments .... ..... .... ..... .... ..... .... .... ..... .... .. 18 Interior mirror . ..... .... ..... .... ..... .... .... ..... .. 4, 65 ISO FIX ..... .... .... ..... .... ..... .... ..... .... .... ..... .... .. 62

J Jac k .... ..... .... .... ..... .... ..... .... ..... 113, 114, 116 Jump leads . .... ..... .... ..... .... ..... .... .... ..... .... 106

K Key Ignition lock ..... .... ..... .... ..... .... .... ..... .. 5, 29 Locking d oors .. .... ..... .... ..... .28, 29, 31, 33 Remove ... .... ..... .... ..... .... ..... .... .... ..... .... .. 16 Starting the engine .. .... ..... .... .... ..... .. 5, 15 Key numbers .. ..... .... ..... .... ..... .... .... ..... .... .... 2 Keys ... ..... .... .... ..... .... ..... .... ..... .... .... ..... .... .... 2

L

M

Lashing ey es .. .... ..... .... ..... .... .... ..... .... ..... .. 42 Leather trim ... .... ..... .... ..... .... .... ..... .... ..... 142 Light switch .... .... ..... .... ..... .... .... ..... .... . 10, 66 Lighting . .... ..... .... ..... .... ..... .... .... .. 10, 66, 122 Driving abroad .... .... ..... .... .... ..... .... ..... .. 68 Loading . .... ..... .... ..... .... ..... .... .... 85, 103, 150 Loading the vehicle .... ..... .... .... ..... .... ..... 150 Locking d oors .... ..... .... ..... .... .... .... 28, 30, 31 Locking from the inside .. .... .... ..... .... ..... .. 30 Locks .. .... .... ..... .... ..... .... ..... .... .... ..... .... ..... 143 Luggag e comp artm ent C ov er . .... ..... .... ..... .... ..... .... .... ..... .... ..... .. 43 Extension .... .... ..... .... ..... .... .... ..... .... ..... .. 41 Lashing eyes .. ..... .... ..... .... .... ..... .... ..... .. 42 Loading . ..... .... ..... .... ..... .... .... ..... .... ..... 103 Locking .. ..... .... ..... .... ..... .... .... ..... .... . 30, 36 Luggag e comp artm ent cover ..... .... ..... .. 43

Main b eam .... ..... .... .... ..... .... ..... .... ..... . 10, 66 Bulb replacement .. ..... .... ..... .... ..... .... . 122 Control indica tor .... ..... .... ..... .... ..... .... ... 18 Maintenance . ..... .... .... ..... .... ..... .... ..... .... . 130 Air cond itioning system . ..... .... ..... .... ... 81 Anti-freeze protection .... ..... .... .. 134, 138 Brake fluid . ..... .... .... ..... .... ..... .... ..... .... . 136 Brakes .... .... ..... .... .... ..... .... ..... .... ..... .... ... 92 Cataly tic conv erter ..... .... ..... .... ..... .... ... 91 Engine oil ... ..... .... .... ..... .... ..... .... ..... .... . 132 Fuel consumption .. ..... .... ..... .... ..... .... ... 85 Tyre pressure . .... .... ..... .... ..... .... ..... .... ... 97 Tyres . ..... .... ..... .... .... ..... .... ..... .... ..... .... ... 98 Windscreen wipers ..... .... ..... .... ..... .... . 137 Manual transmission . ..... .... ..... .... ..... .... ... 14 Mirrors .. ..... .... ..... .... .... ..... .... ..... .... ..... ... 4, 65 Misted wind ow s . .... .... ..... .... ..... .... ..... .... ... 77 Mobile telephone .. .... ..... .... ..... .... ..... .... ... 26

N N um ber plate light .... ..... .... ..... .... ..... . 31, 37 N um ber plate lights Bulb replacement .. ..... .... ..... .... ..... .... . 126 N um ber plate lighting ... .... ..... .. 31, 37, 126

161 O

R

O ctane numbers . .... ..... .... ..... .... .... ...86, 146 O dometer ... .... ..... .... ..... .... ..... .... .... ..... .... .. 22 O il chang e .. .... ..... .... ..... .... ..... .... .... ..... .... 133 O il consumption .. .... ..... .... ..... .... .... .132, 146 O il filter change .. .... ..... .... ..... .... .... ..... .... 133 O il level ... .... .... ..... .... ..... .... ..... .... .... ..... .... 132 O il pressure .... ..... .... ..... .... ..... .... .... ..... .... .. 21 O ils . .... ..... .... .... ..... .... ..... .... ..... .... .... ..... .... 145 O perating temperature ... ..... .... .... ..... .... .. 83 O utside temperature ga uge .... .... ..... .... .. 25 O verrun ... .... .... ..... .... ..... .... ..... .... .... ..... 83, 85

Radio . .... .... ..... .... ..... .... ..... .... .... ..... .... ..... .. 26 Radio eq uipm ent (CB) ..... .... .... ..... .... ..... .. 26 Radio rem ote control . ..... .... .... ..... .... ..... .. 31 Rear light cluster ..... .... ..... .... .... ..... .... . 10, 66 Bulb replacem ent ... ..... .... .... ..... .... ..... 124 Rear w indow wash system .. .... ..... ... 12, 137 Rear w indow wiper . .... ..... .... .... ..... .... ..... .. 12 Refuelling .. ..... .... ..... .... ..... .... .... ..... .... ..... .. 87 Fuel filler ca p .. ..... .... ..... .... .... ..... .... ..... .. 87 Replacement key s .. .... ..... .... .... ..... .... ..... .. 28 Reversing lights .. ..... .... ..... .... .... ..... .... ..... .. 67 Bulb replacem ent ... ..... .... .... ..... .... ..... 124 Roof load ... ..... .... ..... .... ..... .... .... .. 82, 85, 150 Roof rac k ... ..... .... ..... .... ..... .... .... ..... .... ..... 102 Roof rac ks . ..... .... ..... .... ..... .... .... .. 82, 85, 102 Ruc ksac k ... ..... .... ..... .... ..... .... .... ..... .... ..... .. 46 Running-in . ..... .... ..... .... ..... .... .... ..... .... ..... .. 82 Brakes .... ..... .... ..... .... ..... .... .... ..... .... ..... .. 92

P Paintwork dama ge . ..... .... ..... .... .... ..... .... 141 Parking ... .... .... ..... .... ..... .... ..... .... .... ..... .... .. 16 Parking lights . ..... .... ..... .... ..... .... .... ..... 10, 66 Bulb replacement ..... .... ..... .... .... ..... .... 123 Parking the vehicle . ..... .... ..... .... .... ..... .... .. 16 Parts ... ..... .... .... ..... .... ..... .... ..... .... .... ..... .... .. 17 Peda ls ..... .... .... ..... .... ..... .... ..... .... .... ..... .... .. 83 Performance ... ..... .... ..... .... ..... .... .... ..... .... 147 Petrol . ..... .... .... ..... .... ..... .... ..... .... .... ... 86, 146 Pinking .... .... .... ..... .... ..... .... ..... .... .... ..... .... .. 86 Pollen filter . .... ..... .... ..... .... ..... .... .... ..... .... .. 80 Power assisted steering, see Electric power steering . .... .... ..... .... ..... .... ..... .... .... ..... 18, 82 Protection against unauthoriz ed use ..... .... ..... .... .2, 5, 29, 37 Pushing, towing .. .... ..... .... ..... .... .... ..... .... 106

S Safety .... .... ..... .... ..... .... ..... .... .... ..... .... ..... .. 50 Safety accessories .. .... ..... .... .... .. 62, 65, 110 Safety net .. ..... .... ..... .... ..... .... .... ..... .... ..... .. 43 Saving energy .... ..... .... ..... .... .... ..... .... . 83, 84 Sea t belts .. ..... .... ..... .... ..... .... .... ..... .... ... 5, 51 Sea t height adjustm ent .. .... .... ..... .... ..... .... 4 Sea ts .. .... .... ..... .... ..... .... ..... .... .... ..... .... ... 5, 39 Self-diagnostics . ..... .... ..... .... .... ..... .... . 60, 95 Self-help .... ..... .... ..... .... ..... .... .... ..... .... ..... 106 Radio remote control .. .... .... ..... .... ..... .. 32 Serv ic e interv al display ... .... .... ..... .... ..... 130 Serv ic e work ... .... ..... .... ..... .... .... ..... .... ..... .. 16

S id e airba gs .. ..... .... .... ..... .... ..... .... ..... .... ... 59 S ig nal sy stem ..... .... .... ..... .... ..... .... ..... . 10, 11 S ilencer, see Exhaust sy stem .. .... ..... .... ... 90 S pare k eys . .... ..... .... .... ..... .... ..... .... ..... .... ... 28 S pare w heel .. ..... .... .... ..... .... ..... .... ..... .... . 111 S peed ... ..... .... ..... .... .... ..... .... ..... .... ..... . 84, 85 Fuel consumption .. ..... .... ..... .... ..... . 84, 85 S peedometer ..... .... .... ..... .... ..... .... ..... .... ... 22 S ta rter switch ..... .... .... ..... .... ..... .... ..... .... .... ..5 S ta rting the engine ... ..... .... ... 5, 15, 29, 106 Self-help .... ..... .... .... ..... .... ..... .... ..... .... . 106 S team-jet cleaners .... ..... .... ..... .... ..... .... . 143 S teering column lock . ..... .... ..... .... ..... ... 5, 16 S torage box .. ..... .... .... ..... .... ..... .... ..... .... ... 45 S un roof ..... .... ..... .... .... ..... .... ..... .... ..... .... ... 71 S un shade . .... ..... .... .... ..... .... ..... .... ..... .... ... 71 S un v isors .. .... ..... .... .... ..... .... ..... .... ..... .... ... 48

T Tachometer .. ..... .... .... ..... .... ..... .... ..... .... ... 22 Tail lights ... .... ..... .... .... ..... .... ..... .... ..... .... ... 66 Bulb replacement .. ..... .... ..... .... ..... .... . 124 Tailgate ..... .... ..... .... .... ..... .... ..... .... ..... . 30, 35 Tank Fuel gauge ..... .... .... ..... .... ..... .... ..... .... ... 23 Technical data .. .... .... ..... .... ..... .... ..... .... . 144 Telephone, see Mobile telephone ... .... ... 26 Temporary spare wheel . .... ..... .... ..... .... . 101 The first 600 miles / 1000 km .. .... ..... .... ... 82 Tightening torque . .... ..... .... ..... .... ..... .... . 117 Tools . .... ..... .... ..... .... .... ..... .... ..... .... ..... .... . 111 Towing . ..... .... ..... .... .... ..... .... ..... .... .. 108, 109 Towing equipment .... ..... .... ..... .... ..... .... . 103 Towing eye ... ..... .... .... ..... .... ..... .... .. 108, 109

162 Trailer/caravan towing .... ..... .... .... ..... .... 102 Transm ission .. ..... .... ..... .... ..... .... .... ..... .... .. 14 Tray .... ..... .... .... ..... .... ..... .... ..... .... ... 45, 46, 47 Tread dep th ... ..... .... ..... .... ..... .... .... ..... .... .. 98 Trip odometer ..... .... ..... .... ..... .... .... ..... .... .. 22 Triple information display .... .... .... ..... .... .. 24 Turn signal lights .... ..... .... ..... .... .... ..... .... .. 11 Turn signals Bulb replacement ..... .... ..... .... .... ..... .... 124 Tyre chains . .... ..... .... ..... .... ..... .... .... .100, 152 Tyre condition ..... .... ..... .... ..... .... .... ..... .... .. 98 Tyre pressure .. ..... .... ..... .... ..... .... .82, 97, 152

U Underb od y wash .... ..... .... ..... .... .... ..... .... 143 Unlead ed fuel ..... .... ..... .... ..... .... .... ... 86, 146 Used oil ... .... .... ..... .... ..... .... ..... .... .... ..... .... 133

V Vauxhall Service . .... ..... .... ..... .... .... ...16, 128 Vehicle care .... ..... .... ..... .... ..... .... .... ..... .... 140 Vehicle decomm issioning ..... .... .... ..... .... 139 Vehicle identification number .. .... ..... .... 144 Vehicle key s, see Key s . .... ..... .... .... ..... .... ..28 Vehicle recommissioning . ..... .... .... ..... .... 139 Vehicle tools ... ..... .... ..... .... ..... .... .... ..... .... 111 Ventilation .. .... ..... .... ..... .... ..... .... .... ..... 72, 76

W Warning buzzers .... .... ..... .... .... ..... .... ..... .. 15 Warning triangle, ... .... ..... .... .... ..... .... ..... .. 65 Weights . .... ..... .... ..... .... ..... .... .... ..... .... ..... 150 Wheels ... .... ..... .... ..... .... ..... .... .... ..... .... . 96, 98 Wheels, tyres .. .... ..... .... ..... .... .... ..... .... ..... .. 96 Windows .... ..... .... ..... .... ..... .... .... ..... .... . 69, 70 Demisting and defrosting ... ..... .... . 77, 79 Windscreen wash sy stem .... .... ..... .... ..... .. 12 Anti-freeze protec tion . .... .... ..... .... ..... 138 C apacities .. .... ..... .... ..... .... .... ..... .... ..... 155 wash bottle .... ..... .... ..... .... .... ..... .... ..... 137 Windscreen wipers .. .... ..... .... .... ..... ... 12, 137 Winter op eration Battery ... ..... .... ..... .... ..... .... .... ..... .... ..... .. 83 C oolant, a nti-freeze .... .... .... ..... .... ..... 134 Fuel consum ption ... ..... .... .... ..... .... ..... .. 85 Heating .. ..... .... ..... .... ..... .... .... ..... .... ..... .. 72 Locks .. .... ..... .... ..... .... ..... .... .... ..... .... ..... 143 Tyre chains . .... ..... .... ..... .... .... ..... .100, 152 Window demisting and defrosting ... .. 77 Windscreen wa sh system, antifreeze p rotection ... .... .... ..... .... ..... 138 Winter tyres .... .... ..... .... ..... .... .... ..... . 100, 152

TS1649-A-07.qxd

15/06/2006

07:10

Page 1

Owner’s Manual

AGILA

Operation, Safety and Maintenance

Reproduction or translation, in whole or in parts, is not permitted without prior written consent from Vauxhall Motors Ltd. All rights as understood under the copyright laws are explicitly reserved by Vauxhall Motors Ltd. All information, illustrations and specifications contained in this manual are based on the latest production information available at the time of publication. The right is reserved to make changes at any time without notice. Edition: July 2006.

TS 1525-A-07

AG I L A

©Copyright by Vauxhall Motors Ltd., England.