A320 Normal Procedures Scanflow

AIRBUS A320 NORMAL PROCEDURES WALKTHROUGH

LIM SHING KAI

11 NOV 2013

AIRBUS A320 NORMAL PROCEDURES – SAFETY EXTERIOR INSPECTION (PM)

SAFETY EXTERIOR INSPECTION 1, 2 *WHEEL CHOCKS CHECK IN PLACE 1, 2 *LDG GEAR DOORS CHECK IN POSITION 3 *APU AREA CHECK CLEAR

3

2

AIRCRAFT DOCUMENTATION (PF & PM) TECHNICAL LOGS ADDL, Tech Log, Cabin Defect Log BEFORE SITTING DOWN OVERHEAD CB & MAINTENANCE PANELS REAR CB PANEL *GEAR PINS & COVERS

LIM SHING KAI

1

CHECK

CHECK CHECK CHECK

11 NOV 2013

AIRBUS A320 NORMAL PROCEDURES – PRELIMINARY COCKPIT PREPARATION (PM)

6

4 5

3

7

3

2

AIRCRAFT POWER UP 1 ENG MSTR 1 & 2 MODE SELECTOR 2 L/G GEAR 3 CAPT & FO WIPERS

IF > 25.5V, OR IF A/C HAS BEEN ELECTRICALLY SUPPLIED DURING THE LAST 6 HOURS BAT 1 & 2 AUTO EXT PWR (AVAIL LIGHT ON) ON

OFF NORM DOWN OFF

IF A/C IS NOT ELECTRICALLY SUPPLIED FOR 6 HOURS OR MORE, PERFORM BATTERY CHECK: 4 BAT 1 & 2 CHECK OFF BAT 1 & 2 VOLTAGE CHECK >25.5V IF < 25.5V BAT 1 & 2 5 EXT PWR

LIM SHING KAI

1

APU FIRE TEST/START 6 APU FIRE SW AGENT LIGHTS APU FIRE TEST 7 APU MASTER APU START EXT PWR

IN & GUARDED OUT PRESS ON ON AS RQRD

AUTO ON

11 NOV 2013

AIRBUS A320 NORMAL PROCEDURES – PRELIMINARY COCKPIT PREPARATION (PM) (CONT)

12

5

4 6

3 2 1

11

LIGHTS 1 *COCKPIT LIGHTS

7

PROBE / WINDOW HEAT 2 PROBE/WINDOW HEAT

AUTO

AIR COND 3 APU BLEED X-BLEED SELECTOR 4 ZONE TEMP SELECTORS

CHECK

OXYGEN 6 OXY CREW SUPPLY

SET ON

LIM SHING KAI

PRESS (HOLD 3 SEC) CHECK MEL / MAINT CHECK OIL QTY CHECK QTY INDICES CHECK O2 LEVEL CHECK BRK TEMP

CHECK POSITION RETRACTED/DISARMED

BRAKES 10 *PARKING BRAKE ON 11 *ACCU & BRAKES PRESS INDICATOR CHECK

ON AUTO AS RQRD

ELEC 5 ELEC PANEL

ECAM 7 *RCL *STS *ENG *HYD *DOOR *WHEEL

FLIGHT CONTROLS 8 *FLAP 9 *SPEEDBRAKE

AS RQRD

9

8 10

ALTN BRAKING SYSTEM (1ST FLT OF DAY) 12 Y ELEC PUMP CHECK OFF CHOCKS IN PLACE 13 PARK BRAKE OFF BRAKE PEDALS PRESS MAX BRAKE PRESSURE BTW 2000 & 2700PSI (1000psi for some aircraft, system is selfmodulating for brake pressure) BRAKE PEDALS RELEASE PARK BRAKE ON

13

11 NOV 2013

AIRBUS A320 NORMAL PROCEDURES – PRELIMINARY COCKPIT PREPARATION (CONT) & EXTERIOR INSPECTION (PM) EMERGENCY EQUIPMENT CHECK • Escape ropes stowed • Oxygen masks stowed • Flash lights stowed • Axe stowed • Portable fire extinguisher: o Lockwired o Pressure within green area • Protective breathing equipment (OXYCREW) o Seal intacted o Yellow serviceability indicator not broken • Fire-resistant gloves stowed RAIN REPELLENT AIRCRAFT DOCUMENTATION

CHECK CHECK

FLT DECK DOOR ACCESS SYSTEM ANTI-HIJACK SWITCH SYSTEM PREFLIGHT SECURITY

CHECK CHECK CHECK

LIM SHING KAI

OPERATIONAL DOCUMENTS 1. AFM 2. QRH 3. Tech Log/ Deferred Defects Log 4. Aircraft Radio Licence 5. Certificate of Registration 6. Certificate of Airworthiness 7. Certificate of Maintenance 8. Insurance Certificate 9. ICAO ERG for DG Incidents 10.Flight Crew Licences 11.Quick Access Folder 12.SEP Manual 13.Jepp Enroute & Approach Chartss 14.Jepp Reference Manual 15.Navigation / Fuel Flight Plan 16.MEL 17.Refueling Manual 18.Loadsheet

11 NOV 2013

AIRBUS A320 NORMAL PROCEDURES – COCKPIT PREPARATION: PANEL SCAN SEQUENCE & OXYGEN MASK TEST (PF & PM)

2

1 3 OXYGEN MASK TEST 1 CREW SUPPLY CHECK ON LOUDSPEAKERS ON 2 INT RECEPTION KNOB PRESS OUT-ADJUST 3 INT/RAD SW INT 4 MASK RESET/TEST PRESS & HOLD in direction of arrow Check that blinker turns yellow for a short time, and then goes black. 5 MASK REST/TEST with EMER PRESS SELECTOR PRESS & HOLD Check that blinker turns & remains yellow, as long as emergency pressure selector is pressed. Listen for oxygen flow through loud speakers. 6 MASK RESET/TEST CHECK IN UP POSITION 7 N 100% SELECTOR 100% POSITION 8 EMER PRESS SELECTOR PRESS & CHECK blinker no longer yellow 9 REGUL LO PR message on ECAM DOORS PAGE CHECK OFF

4

6

7 8 5

9

LIM SHING KAI

11 NOV 2013

AIRBUS A320 NORMAL PROCEDURES – COCKPIT PREPARATION: OVERHEAD PANEL (PF) 11

12

10

3 9

2

1

8

7

6 4 5

RECORDER 1 *RCDR GND CTL CVR TEST EVAC 2 CAPT & PURS/CAPT EVAC SW

ON CHECK AS RQRD (CAPT)

ADIRS 3 *ADIRS MODE SELECTORS

ALL NAV

EXTERIOR LIGHTS 4 EXTERIOR LIGHTS

AS RQRD

SIGNS 5 *SEAT BELTS & EXIT SIGNS *EMER EXIT LT CABIN PRESS 6 LDG ELEV AIR COND 7 *PACK FLOW

LIM SHING KAI

ON/AUTO ARM AUTO

ELEC 8 ECAM ELEC PAGE CALL BAT 1 & 2 OFF then ON (CHECK CURRENT) Can both be checked together FUEL 9 *FUEL PUMPS

ON

ENG 1 & 2 FIRE 10 ENG 1 & 2 FIRE PB CHECK IN/GUARDED AGENT 1 & 2 LIGHT CHECK OUT ENG 1 & 2 TEST PB PRESS MSTR WARN PRESS To check that it cancels the FIRE alerts AUDIO SWITCHING PANEL 11 AUDIO SWITCHING PANEL

NORM

3RD AUDIO CONTROL PANEL 12 PA RECEPTION KNOB

SELECT RECEPTION

AS RQRD

11 NOV 2013

AIRBUS A320 NORMAL PROCEDURES – COCKPIT PREPARATION: GLARESHIELD & INSTRUMENT PANELS (PF & PM)

6

7

8

1

9 4 5

GLARESHIELD GLARESHIELD LIGHT & FLOOD LIGHT 1 *BARO REF 2 *FD 3 *ILS / LS

3

2

AS RQRD SET CHECK ON AS RQRD

EFIS CONTROL PANEL 4 *ND MODE & RANGE 5 *VOR/ADF SELECTION 6 *CSTR PB

AS RQRD AS RQRD AS RQRD

FCU (PF) 7 *SPD MACH WINDOW 8 *HDG V/S-TRK FPA PB 9 *ALT WINDOW

DASHED HDG V/S INITIAL EXPECTED CLEARANCE ALT

10

11

13

12

INSTRUMENT PANEL 10 PFD & ND BRIGHTNESS AS RQRD 11 LOUDSPEAKERS SET 12 PFD CHECK • Check PFD/ND displays not transferred • Check for correct display when ATT & HDG are available • Check IAS, FMA, initial target ALT, altimeter settings, heading & attitude display 13 ND CHECK • Check for correct display • Crosscheck compass indication on ND & DDRMI • Check ground speed